Download 50HP86

FILE NO. 050-200624GR
(MFR’S VERSION A)
SERVICE MANUAL
50" PLASMA
COLOR TELEVISION
50HP86
The above model is classified as a green product (*1), as indicated by the underlined serial number.
This Service Manual describes replacement parts for the green product. When repairing this green
product, use the part(s) described in this manual and lead-free solder (*2).
For (*1) and (*2), see the next page.
DOCUMENT CREATED IN JAPAN, July, 2006 GREEN
(*1)
GREEN PRODUCT PROCUREMENT
The EC is actively promoting the WEEE & RoHS Directives that define standards for recycling
and reuse of Waste Electrical and Electronic Equipment and for the Restriction of the use of
certain Hazardous Substances. From July 1, 2006, the RoHS Directive will prohibit any
marketing of new products containing the restricted substances.
Increasing attention is given to issues related to the global environmental. Toshiba Corporation
recognizes environmental protection as a key management tasks, and is doing its utmost to
enhance and improve the quality and scope of its environmental activities. In line with this,
Toshiba proactively promotes Green Procurement, and seeks to purchase and use products,
parts and materials that have low environmental impacts.
Green procurement of parts is not only confined to manufacture. The same green parts used in
manufacture must also be used as replacement parts.
(*2)
LEAD-FREE SOLDER
This product is manufactured using lead-free solder as a part of a movement within the consumer
products industry at large to be environmentally responsible. Lead-free solder must be used in
the servicing and repair of this product.
WARNING
This product is manufactured using lead free solder.
DO NOT USE LEAD BASED SOLDER TO REPAIR THIS PRODUCT !
The melting temperature of lead-free solder is higher than that of leaded solder by 86°F to 104°F
(30°C to 40°C). Use of a soldering iron designed for lead-based solders to repair product made
with lead-free solder may result in damage to the component and or PCB being soldered. Great
care should be made to ensure high-quality soldering when servicing this product  especially
when soldering large components, through-hole pins, and on PCBs  as the level of heat
required to melt lead-free solder is high.
A1-1
SERVICING NOTICES ON CHECKING
1. KEEP THE NOTICES
As for the places which need special attentions,
they are indicated with the labels or seals on the
cabinet, chassis and parts. Make sure to keep the
indications and notices in the operation manual.
2. AVOID AN ELECTRIC SHOCK
There is a high voltage part inside. Avoid an
electric shock while the electric current is
flowing.
11.When you remove the cover, do not scratch the
FPC on both ends of PDP Module.
12.Hold the four ends holder and be careful not to
touch the glass area.
13.Take care for the damage of vacuum exhaust
pipe due to a collision.
14.Moisture condensation may damage the PDP
Module.
So, leave it for 48 hours at the service room.
5. PUT PARTS AND WIRES IN THE
ORIGINAL POSITION AFTER
ASSEMBLING OR WIRING
3. USE THE DESIGNATED PARTS
The parts in this equipment have the specific
characters of incombustibility and withstand
voltage for safety. Therefore, the part which is
replaced should be used the part which has
the same character.
Especially as to the important parts for safety
which is indicated in the circuit diagram or the
table of parts as a
mark, the designated
parts must be used.
There are parts which use the insulation
material such as a tube or tape for safety, or
which are assembled in the condition that
these do not contact with the printed board.
The inside wiring is designed not to get closer
to the pyrogenic parts and high voltage parts.
Therefore, put these parts in the original
positions.
4. BE CAREFUL WITH THE PDP PANEL
1. When you handle the PDP Filter you must
wear the gloves twice, because, you are to
avoid soil it by your sweat and dust.
2. When you lift the PDP Filter you should hold it
with the palm of your hand.
Don’t pick up it with your fingers.
3. The back side of PDP Filter tends to damaged.
Since there is no coating.
Therefore, it put into the packing box at the
time of delivery, without piling up even at the
time of unused.
Also, when you take out it from a packing box,
be careful of the rubbing.
4. When the surface becomes dirty, wipe it with a
soft cloth as you draw a circle.
When it is dirty hardly, wipe it with a cloth
ethanol infiltrated.
Don’t use ethanol for the back side.
5. Do not apply it to direct sunshine so that the
characteristic may change.
6. When you inspect the surface (the scratch, the
dirt and the air bubble), use the fluorescent
light.
7. When you use SCREW DRIVER and SCREW,
be careful of a metallic powder being mixed.
8. Do not damage the PDP Module with a
DRIVER.
9. Do Handling with the PDP Module by 2
persons.
10.There is a step difference between the cover
and PDP Module.
So, when you remove the screws, place a
cushion on it so that the PDP Module is not
being scratched.
Then remove the screws carefully.
A1-2
6. PERFORM A SAFETY CHECK AFTER
SERVICING
Confirm that the screws, parts and wiring which
were removed in order to service are put in the
original positions, or whether there are the
portions which are deteriorated around the
serviced places serviced or not. Check the
insulation between the antenna terminal or
external metal and the AC cord plug blades.
And be sure the safety of that.
(INSULATION CHECK PROCEDURE)
1. Unplug the plug from the AC outlet.
2. Remove the antenna terminal on TV and turn
on the TV.
3. Insulation resistance between the cord plug
terminals and the eternal exposure metal
[Note 2] should be more than 2.5M ohm by
using the 500V insulation resistance meter
[Note 1].
4. If the insulation resistance is less than 2.5M
ohm, the inspection repair should be
required.
[Note 1]
If you have not the 500V insulation
resistance meter, use a Tester.
[Note 2]
External exposure metal: Antenna terminal
Screw
21pin jack
Side RCA jack
Rear RCA jack
Headphone jack
HOW TO ORDER PARTS
Please include the following informations when you order parts. (Particularly the VERSION LETTER.)
1. MODEL NUMBER and VERSION LETTER
The MODEL NUMBER can be found on the back of each product and the VERSION LETTER can be
found at the end of the SERIAL NUMBER.
2. PART NO. and DESCRIPTION
You can find it in your SERVICE MANUAL.
IMPORTANT
When you exchange IC and Transistor with a heat sink, apply silicon grease (YG6260M) on the contact
section of the heat sink. Before applying new silicon grease, remove all the old silicon grease.
(Old grease may cause damage to the IC and Transistor).
PANEL LOCK
To unlock the Panel Lock, please follow the steps below.
1. Turn Unit ON.
2. Press and hold the ‘VOLUME DOWN’ key on the front panel for more than 10 seconds.
3. The Panel Lock has now been cleared.
A1-3
TABLE OF CONTENTS
GREEN PRODUCT PROCUREMENT ........................................................................................
LEAD-FREE SOLDER ................................................................................................................
SERVICING NOTICES ON CHECKING .....................................................................................
HOW TO ORDER PARTS ..........................................................................................................
IMPORTANT ...............................................................................................................................
PANEL LOCK ..............................................................................................................................
TABLE OF CONTENTS ..............................................................................................................
GENERAL SPECIFICATIONS ...................................................................................................
DISASSEMBLY INSTRUCTIONS
1.EXCHANGE METHOD OF PDP MODULE ...........................................................................
2. REMOVAL AND INSTALLATION OF FLAT PACKAGE IC ..................................................
SERVICE MODE LIST ................................................................................................................
WHEN REPLACING EEPROM (MEMORY) IC ..........................................................................
FUNCTION OF PCB ....................................................................................................................
ELECTRICAL ADJUSTMENTS ..................................................................................................
TROUBLESHOOTING GUIDE ...................................................................................................
BLOCK DIAGRAM
SCALER/LVDS/MICON/ADC/VIDEO ENHANCER/REGULATOR ........................................
AV SWITCH/AV SWITCH2/AV JACK/STEREO/SOUND AMP/JACK ....................................
TUNER/POWER ......................................................................................................................
INTERFACE .............................................................................................................................
MICON2 ...................................................................................................................................
PRINTED CIRCUIT BOARDS
AV/REMOCON ........................................................................................................................
SCALER ...................................................................................................................................
SIDE JACK/OPERATION/FILTER ..........................................................................................
SCHEMATIC DIAGRAMS
AV SWITCH2 ...........................................................................................................................
SWITCH/AMP ..........................................................................................................................
AV JACK ..................................................................................................................................
STEREO ..................................................................................................................................
SOUND AMP/HEADPHONE AMP ..........................................................................................
POWER ...................................................................................................................................
AV JACK2 ................................................................................................................................
TUNER .....................................................................................................................................
MICON .....................................................................................................................................
SCALER ...................................................................................................................................
ADC ..........................................................................................................................................
VIDEO ENHANCER ................................................................................................................
LVDS ........................................................................................................................................
JACK ........................................................................................................................................
AV SWITCH .............................................................................................................................
REGULATOR ...........................................................................................................................
INTERFACE_HDMI IC ............................................................................................................
HDMI MICON2 .........................................................................................................................
OPERATION/FILTER ..............................................................................................................
SIDE JACK PCB ......................................................................................................................
WAVEFORMS .............................................................................................................................
MECHANICAL EXPLODED VIEWS ...........................................................................................
MECHANICAL REPLACEMENT PARTS LIST .........................................................................
ELECTRICAL REPLACEMENT PARTS LIST ...........................................................................
A2-1
A1-1
A1-1
A1-2
A1-3
A1-3
A1-3
A2-1
A3-1~A3-5
B1-1~B1-8
B2-1, B2-2
C-1
C-2
C-3
D-1~D-5
E-1~E-7
F-1, F-2
F-3, F-4
F-5, F-6
F-7, F-8
F-9, F-10
G-1~G-4
G-5~G-8
G-9, G-10
H-1, H-2
H-3, H-4
H-5, H-6
H-7, H-8
H-9, H-10
H-11, H-12
H-13, H-14
H-15, H-16
H-17, H-18
H-19, H-20
H-21, H-22
H-23, H-24
H-25, H-26
H-27, H-28
H-29, H-30
H-31, H-32
H-33, H-34
H-35, H-36
H-37, H-38
H-39, H-40
I-1~I-3
J-1~J-3
K1-1~K1-3
K2-1~K2-6
GENERAL SPECIFICATIONS
G-1
TV
System
PDP
PDP Size / Visual Size
Number of Pixels(H x V)
Color System
Speaker
Main
Tweeter
Sound Output
G-2
Tuning
System
Broadcasting System
Tuner and
Receive CH
Intermediate
Frequency
G-3
Signal
G-4
Power
Digital
Analog
Preset CH
Stereo/Dual TV Sound
Tuner Sound Muting
Video Signal
RGB Signal
Audio Signal
Power Source
Power Consumption
Protector
G-5
Regulation
G-6
Temperature
G-7
G-8
Operating Humidity
Clock and
Clock
Timer
Sleep Timer
Position
Size
Impedance
Size
Impedance
MAX
10%(Typical)
Analog
Digital
System
Destination
CH Coverage
Picture(FP)
Sound(FS)
FP-FS
Input Level
Output Level
S/N Ratio (Weighted)
Horizontal Resolution at DVD Mode
Output Level
Input Level
Output Level
at DVD
at TV
Digital Output Level
S/N Ratio at DVD (Weighted)
Harmonic Distortion
Frequency Response :
at DVD
at Video CD
at SVCD
at CD
AC
DC
at AC
at DC
Stand by (at AC)
Per Year
Energy Star
Power Fuse
Safety Circuit
IC Protector(Micro Fuse)
Safety
Radiation
X-Radiation
Operation
Storage
Max Time
Step
Program
Program
On Timer
Off Timer
Game Timer
Wake Up Timer
Timer Back-up (at Power Off Mode)
more than
A3-1
49.95 inch / 1268.7 mmV
1366(H) x 768(V)
NTSC
4 Speaker
Front
2.2 x 5.0 inch
4 ohm
2.0 inch
8 ohm
10W + 10W
--US System M
-1Tuner
USA(W/ CABLE)
2 - 69, 4A, A-5 - A-1,
A - I, J - W, W+1 - W+84
-45.75MHz
41.25MHz
4.50MHz
No
US-Stereo
Yes
1 V p-p/75 ohm
1 V p-p/75 ohm
-----8.0dBm/50k ohm
--8 dBm/1k ohm (0dBm=0.775Vrms)
0-600mV /1k ohm (Variable out mode)
--0.02% (1KHz)
----120V AC 60Hz
--520 W at AC 120 V 60 Hz
-1 W at AC 120 V 60 Hz
-kWh/Year
Yes
Yes
Yes
No
CSA
IC
--+/-0oC ~ +40oC
-20oC ~ +60oC
Less than 80% RH
Yes
120 Min
10 Min
Yes
No
Yes
No
-Min
Sec
GENERAL SPECIFICATIONS
G-9
Remote
Control
Unit
Glow in Dark Remocon
Remocon Format
Format
Custom Code
Power Source
Total Keys
Keys
Multi Brand Keys
Voltage(D.C)
UM size x pcs
Power
Input
Display
Mute
1
2
3
4
5
6
7
8
9
0
100 / +10
CH Return / Ent
CH +
CH VOL +
VOL SLEEP
Picture Size
UP
LEFT / FAV MENU/ENTER/DVD MENU
RIGHT / FAV +
DOWN
EXIT
TV
CBL/SAT
VCR
DVD
ENTER
PAUSE
PLAY
STOP
REW
FF
SKIP/SEARCH|<<
SKIP/SEARCH>>|
TOP MENU
REC
CLEAR
TV/VCR
A3-2
RC-KK
Yes
TOSHIBA
TOSHIBA
40-BF h
3V
UM-4 x 2 pcs
44
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
GENERAL SPECIFICATIONS
G-10
Features
Auto Shut Off
Power On Memory
Auto Search
DNR
Yes
Yes
No
Yes
3D
Yes
3D
Comb Filter
Just Clock Function
Game Position
Auto Setup(Language/CH Program)
Picture Setting(TV)
Mode(Picture Preference)
Brightness , Contrast , Color
Tint
Sharpness
Color Temperature
Cable Clear
Picture Setting(PC)
BRIGHTNESS , CONTRAST
HOR POSITION , VER POSITION
PHASE , CLOCK
AUTO ADJUST
RED , GREEN , BLUE
Audio
MTS
Tone Control (Bass/Treble/Balance)
Stable Sound
Surround
BBE
SRS WOW (SRS 3D/Focus/Tru Bass)
Valiable Audio Out
Tuning
CH Program
TV/Cable
ADD/ERASE
Screen Saver
Inversion(Reverse)
Full White(White)
Screen Saver(Picture Shift)
Side Panel Color
Label
CH Label
Video Label
Favorite CH
V-Chip
RRT Setup
Lock
Hotel Lock
Channel Lock
Video Lock
Panel Lock
OSD Language
Closed Caption
CC Advanced
Picture Size
Picture Scroll
Aspect
Backlight
PFC(Power Factor circuit)
Freeze frame
PIP/POP
Digital Out
Dolby Digital
MPEG
PCM
DTS
PC Monitor Input
VGA (640x480)
VGA (720x400)
WVGA (848x480)
SVGA (800x600)
XGA (1024x768)
WXGA (1280x768)
WXGA (1280x720)
WXGA (1360x768)
SXGA (1280x1024)
A3-3
No
No
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
No
Yes
Yes
Yes
Yes
No
No
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
No
No
No
Yes
Yes
Yes
English
Yes
French
No
Yes
Yes
Yes
No
Yes
No
No
No
No
No
No
Yes
Yes (60Hz)
No
Yes (60Hz)
Yes (60Hz)
Yes (60Hz)
Yes (60Hz)
Yes (60Hz)
Yes (60Hz)
No
Spanish
GENERAL SPECIFICATIONS
HDMI Input
VGA (640x480)
720x480i (4:3)
720x480i (16:9)
720x480p (4:3)
720x480p (16:9)
720x576i (4:3)
720x576i (16:9)
720x576p (4:3)
720x576p (16:9)
1280x720p
1920x1080i
Component Input
G-11
Accessories
Owner's Manual
720x480i (4:3)
720x480i (16:9)
720x480p (4:3)
720x480p (16:9)
720x576i (4:3)
720x576i (16:9)
720x576p (4:3)
720x576p (16:9)
1280x720p
1920x1080i
Language
w/Guarantee Card
Remote Control Unit
Rod Antenna
Poles
Terminal
Loop Antenna (W/ Antenna Change Plug)
Terminal
U/V Mixer
DC Car Cord (Center+)
Guarantee Card
Warning Sheet
Circuit Diagram
Antenna Change Plug
Service Facility List
Important Safeguard
Dew/AHC Caution Sheet
Quick Set-up Sheet
Battery
UM size x pcs
OEM Brand
AC Adapter
AC Cord (for AC Adapter)
AC Cord
AV Cord (2Pin-1Pin)
HDMI-DVI Cable
Registration Card
300 ohm to 75 ohm Antenna Adapter
Information Sheet(for IMPORTANT NOTICE)
Information Sheet(for Picture Shift)
A3-4
Yes
Yes (60Hz)
Yes (60Hz)
Yes (60Hz)
Yes (60Hz)
Yes (60Hz)
No
No
No
No
Yes (60Hz)
Yes (60Hz)
Yes
Yes (60Hz)
Yes (60Hz)
Yes (60Hz)
Yes (60Hz)
No
No
No
No
Yes (60Hz)
Yes (60Hz)
English / French
Yes
Yes
No
No
No
No
No
No
No
No
No
No
No
No
Yes
UM-4 x 2 pcs
No
No
No
Yes
No
No
No
No
No
Yes
GENERAL SPECIFICATIONS
G-12
Interface
Switch
Indicator
Terminals
G-13
G-14
Set Size
Weight
G-15
Carton
Side
Power (Tact)
System Select
Main Power SW
Channel Up/Menu Up
Channel Down/Menu Down
Volume Up/Menu >
Volume Down/Menu <
Input Select
Menu
Main Power SW
Power / Stand-by
On Timer
Rear
Video Input 1
Audio Input
S- Input
Video Input 2
Audio Input
S- Input
Video Output
Audio Output
Component In 1
Audio Input (Component In use)
Component In 2
Audio Input (Component In use)
Other Terminal
Euro Scart (21Pin)
PC Monitor Input (D-Sub)
Audio Input
HDMI Input 1
Audio Input(DVI 1)
HDMI Input 2
Audio Input(DVI 2)
Sub Woofer Out
Diversity
Digital Audio Out (Coaxial)
Digital Audio Out (Optical)
IR Pass Through
Ext Speaker
DC Jack 12V(Center +)
VHF/UHF Antenna Input(Analog)
AC Inlet
Side
Video Input 3
Audio Input
S- Input
Other Terminal
Approx.
W x D x H (mm)
Net Approx.
Gross Approx.
Master Carton
Content
Material
Dimensions
W x D x H(mm)
Description of Origin
Gift Box
Material
Dimensions
W x D x H(mm)
Description of Origin
Drop Test
G-16
Material
G-17
Environment
Height (cm)
Container Stuffing
Cabinet
Cabinet Front
Cabinet Rear
PCB
Non-Halogen
Eyelet
Environmental standard requirement (by buyer)
Pb-free
Measures for Whisker
A3-5
Yes
No
No
Yes
Yes
Yes
Yes
Yes
No
No
Yes(GREEN / RED)
No
RCA x 1
RCA x 2(L/MONO, R)
Yes
RCA x 1
RCA x 2(L/MONO, R)
Yes
RCA x 1
RCA x 2(Variable L, R)
RCA x 3
RCA x 2(L/MONO, R)
RCA x 3
RCA x 2(L/MONO, R)
No
No
Yes
RCA x 2(L/MONO, R)
Yes
PC Monitor Audio Input Alternative
Yes
Mini Pin Jack(d:3.5), STEREO
No
No
No
No
Yes
No
No
F Type
Yes
RCA x 1
RCA x2(L/MONO,R)
Yes
No
1,255 x 391 x 869
51.54kg
(113.5 lbs)
61.5kg
(135.6 lbs)
No
--- Sets
--- / ------Double/Brown
1,360 x 521 x 979
Yes
Natural Dropping At 1 Corner / 2 Edges
/ 4 Surfaces
50(ORION SPEC:31)
68
Sets/40' container
ABS 94V0 Non-DECABROM
Steel
No
Yes
Green procurement of TOSHIBA
Phase3(Phase3A)
Yes
DISASSEMBLY INSTRUCTIONS
1. EXCHANGE METHOD OF PDP MODULE
NOTE
1. Do handling with the PDP Module by 2 persons.
REMOVAL METHOD OF PDP MODULE
1-1: CABINET BACK/COVER BACK
1. Remove the screw.
2. Remove the Cabinet Back and Cover Back.
Cabinet Back
Cover Back
1-2: STAND ASS'Y
1. Spread a sheet on the plane table and place the PDP Module carefully with the panel face down.
2. Remove the screw.
3. Remove the Stand Ass'y.
Stand Ass'y
B1-1
DISASSEMBLY INSTRUCTIONS
1-3: CHASSIS BLOCK
1. Disconnect the connector.
2. Remove the screw.
3. Remove the Chassis Ass'y.
Chassis Ass'y
1-4: PDP MODULE
1. Remove the screw.
2. Remove the Side Jack.
3. Hold the Frame Main carefully and remove the PDP Module.
NOTE
1. When removing the PDP Module, raise the cushion carefully so that you do not scratch the face.
Raise the cushion.
PDP Module
Frame Main
Frame Main
Side Jack
B1-2
DISASSEMBLY INSTRUCTIONS
1-5: PDP FILTER
1. Remove the screw.
2. Remove the Shield Main.
3. Remove the PDP Filter.
Shield Main Top
PDP Filter
Shield Main L
Shield Main R
Shield Main Bottom
B1-3
DISASSEMBLY INSTRUCTIONS
INSTALLATION METHOD OF PDP MODULE
NOTES FOR NEW PDP FILTER HANDLING
1. When you handle the PDP Filter, you must wear gloves to avoid soiling it with sweat and dust.
2. When you lift the PDP Filter, use the palm of your hand. Don’t pick it up with your fingers.
3. The back side of the PDP Filter tends to get damaged, since there is no coating. Therefore, it needs to be put into the
packing box at the time of delivery, even if it is not being used at the time. Also, when you take it out of the packing box, be
careful not to rub the appearance.
4. When the surface becomes dirty, use a cloth which is soft and dust free and wipe it in a circular motion.
When very dirty, lightly use alcohol on the cloth to wipe. Do not use alcohol for the back side.
5. Do not apply it to direct sunlight, the characteristics may change.
6. When you inspect for scratches and dirt, use a light to check for air bubbles on the PDP Filter surface.
1-6: PDP FILTER (PREPARATION)
1. Fix the cushion. (Order the cushion new.)
12345678901234567890123456789012123456789012345678
12345678901234567890123456789012123456789012345678
Cushion
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
Cushion
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
Rear side (No coating)
Cushion
123456789012345678901234567890121234567890123456789
123456789012345678901234567890121234567890123456789
Cushion
[4 ends common]
1234
1234
1234
1234
1234
1234
1234
1234
Apply the cushion on
1234
1234
the light brown paint
1234
1234
with 3mm on both
1234
1234
sides of the cushion.
1234
1234
1234
1234
1234
1234
1234
1234
1234
1234
1234
1234
1234
1234567890123456789012345
1234
1234567890123456789012345
1234
1234567890123456789012345
1234
1234567890123456789012345
1234
1234
1234
3mm
B1-4
3mm
DISASSEMBLY INSTRUCTIONS
NOTES FOR NEW PDP MODULE HANDLING
1. Handle the PDP Module with 2 people.
2. There is a step difference between the cover and the PDP Module, so when you remove the screws, place a cushion on it
to keep the PDP Module from being scratched. Then remove the screws carefully.
3. When you remove the cover, do not scratch the FPC on both ends of PDP Module.
4. Hold all four ends of the holder and be careful not to touch the glass area.
5. Be careful not to damage the vacuum exhaust pipe.
6. Moisture condensation may damage the PDP Module, so leave it in the service room for 48 hours.
7. Reuse the cover, vinyl sheet and screws when returning the PDP Module.
Vacuum Exhaust Pipe
FPC
B1-5
DISASSEMBLY INSTRUCTIONS
1-7: PDP MODULE (PREPARATION)
1. Remove the fixing screw of PCB.
2. Assemble the Wiring Clip. (Use the clips on defective PDP Module)
3. Assemble the Cord Clip. (Use the clips on defective PDP Module)
Cord Clip
Wiring Clip
90˚
90˚
Set CN201 (24V)
B1-6
DISASSEMBLY INSTRUCTIONS
1-8: PDP MODULE
1.
2.
3.
4.
5.
Assemble the Frame Main. (Use the clips on defective PDP Module)
Install the PDP Filter on the set.
Install the Shield Main on the set.
Hold the Frame Main carefully and install the New PDP Module on the set.
Install the Side Jack on the set.
[NG]
Do not smash the cusion. (For all 2 positions)
[4 ends common]
123
123
123
123
123
123
123
123
Cushion 123
123
123
123
123
123
123
123
123
123456789012345
123
123456789012345
123
123456789012345
123
123
123
Pile up the cushion.
B1-7
DISASSEMBLY INSTRUCTIONS
1-9: CHASSIS BLOCK
1. Do the wire fixing as shown in the photo, then install the Chassis Ass'y.
2. Install the Stand Ass'y.
Earth wire of AC Inlet.
Sheet Earth Mark
Band Cord Clamp
Earth wire
Band Cord Clamp
1-10: CABINET BACK/COVER BACK
1.
2.
3.
4.
Check if the wire handlings are correct.
Check if the cushion positions are correct.
Check if the tape positions are correct.
Install the Cabinet Back and Cover Back.
B1-8
DISASSEMBLY INSTRUCTIONS
3. When IC starts moving back and forth easily after
desoldering completely, pickup the corner of the IC using a
tweezers and remove the IC by moving with the IC
desoldering machine. (Refer to Fig. 2-3.)
2. REMOVAL AND INSTALLATION OF
FLAT PACKAGE IC
REMOVAL
NOTE
1. Put Masking Tape (cotton tape) around the Flat Package
IC to protect other parts from any damage.
(Refer to Fig. 2-1.)
Some ICs on the PCB are affixed with glue, so be
careful not to break or damage the foil of each IC leads
or solder lands under the IC when removing it.
NOTE
Masking is carried out on all the parts located within 10
mm distance from IC leads.
Masking Tape
(Cotton Tape)
Blower type IC
desoldering
machine
IC
Tweezers
Fig. 2-1
IC
Fig. 2-3
2. Heat the IC leads using a blower type IC desoldering
machine. (Refer to Fig. 2-2.)
4. Peel off the Masking Tape.
NOTE
5. Absorb the solder left on the pattern using the Braided
Shield Wire. (Refer to Fig. 2-4.)
Do not rotate or move the IC back and forth , until IC
can move back and forth easily after desoldering the
leads completely.
NOTE
Do not move the Braided Shield Wire in the vertical
direction towards the IC pattern.
Blower type IC
desoldering machine
Braided Shield Wire
Soldering Iron
IC
IC pattern
Fig. 2-2
B2-1
Fig. 2-4
DISASSEMBLY INSTRUCTIONS
INSTALLATION
4. When bridge-soldering between terminals and/or the
soldering amount are not enough, resolder using a Thin-tip
Soldering Iron. (Refer to Fig. 2-8.)
1. Take care of the polarity of new IC and then install the new
IC fitting on the printed circuit pattern. Then solder each
lead on the diagonal positions of IC temporarily.
(Refer to Fig. 2-5.)
Thin-tip Soldering Iron
IC
Soldering Iron
Fig. 2-8
5. Finally, confirm the soldering status on four sides of the IC
using a magnifying glass.
Confirm that no abnormality is found on the soldering
position and installation position of the parts around the IC.
If some abnormality is found, correct by resoldering.
Solder temporarily
Solder temporarily
Fig. 2-5
2. Supply the solder from the upper position of IC leads
sliding to the lower position of the IC leads.
(Refer to Fig. 2-6.)
Solder
IC
NOTE
When the IC leads are bent during soldering and/or
repairing, do not repair the bending of leads. If the
bending of leads are repaired, the pattern may be
damaged. So, always be sure to replace the IC in this
case.
Soldering Iron
Supply soldering
from upper position
to lower position
Fig. 2-6
3. Absorb the solder left on the lead using the Braided Shield
Wire. (Refer to Fig. 2-7.)
NOTE
Do not absorb the solder to excess.
Soldering Iron
IC
Braided Shield Wire
Fig. 2-7
B2-2
SERVICE MODE LIST
This unit is provided with the following SERVICE MODES so you can repair, examine and adjust easily.
To enter to the SERVICE MODE function, press and hold both buttons simultaneously on the main unit and on the remote
control for more than the standard time in the appropriate condition. (See below chart.)
Set
Condition
Set Key
Remocon
Key
Standard
Time
TV mode
VOL. DOWN
(Minimum)
0
2 sec.
Releasing of V-CHIP PASSWORD.
TV mode
VOL. DOWN
(Minimum)
1
2 sec.
Initialization of factory TV data.
NOTE: If you set factory initialization, the memories are reset
such as the channel setting, and the POWER ON total
hours.
TV mode
VOL. DOWN
(Minimum)
6
2 sec.
Can be checked of the INITIAL DATA of MEMORY IC.
Refer to the "WHEN REPLACING EEPROM (MEMORY) IC".
ALL mode
VOL. DOWN
(Minimum)
8
2 sec.
Check of the SUM DATA, POWER ON total hours, MICON
VERSION on the screen.
Refer to the "WHEN REPLACING EEPROM (MEMORY) IC".
ALL mode
VOL. DOWN
(Minimum)
9
2 sec.
Display of the Adjustment MENU on the screen.
Refer to the "ELECTRICAL ADJUSTMENT" (On-Screen Display
Adjustment).
Operations
C-1
WHEN REPLACING EEPROM (MEMORY) IC
CONFIRMATION OF CHECK SUM, POWER ON TOTAL HOURS, MICON VERSION .
Initial total of MEMORY IC, POWER ON total hours, MICON VERSION can be checked on the screen. Total hours are
displayed in 16 system of notation.
NOTE: If you set a factory initialization, the total hours is reset to "0".
Please refer to "CONFIRMATION OF INITIAL DATA" when SUM DATA is not corresponding.
1. Turn on the POWER, and set to the TV mode.
2. Set the VOLUME to minimum.
3. Press both VOL. DOWN button on the set and Channel
button (8) on the remote control for more than 2 seconds.
4. After the confirmation of each check sum, POWER ON
total hours, MICON VERSION , turn off the power.
*1 DVP1 is different according to each set.
MICON Version
INIT
: 7097
VOLUME : 2E0E
ROM
: 0000
ADC
: C1BC
DVP1
: 431C *1
DVP2
: 0655
PICENH : 6A3A
PDP ON : 0000
OEC7164A_022
FIG. 1
Initial setting data check sum.
VOLUME CURVE data check sum.
Rom correction data check sum.
AD CONVERTER data check sum.
SCALER data check sum.
DV1000 data check sum.
POWER ON total hours.
= (16 x 16 x 16 x thousands digit value)
+ (16 x 16 x hundreds digit value)
+ (16 x tens digit value)
+ (ones digit value)
CONFIRMATION OF INITIAL DATA
If a service repair is undertaken where it has been required to change the MEMORY IC, the following steps should be taken to
ensure correct data settings while making reference to INITIAL SETTING TABLE (Attached "INITIAL DATA").
1. Turn on the POWER, and set to the TV mode.
2. Set the VOLUME to minimum.
3. Press both VOL. DOWN button on the set and Channel button (6) on the remote control for more than 2 seconds.
ADDRESS and DATA should appear as FIG 2.
ADDRESS
DATA
INIT 0000 00
PDP ON 0000
OEC7164A_022
INIT :0000
ROM
: 0000
VOLUME : 2E0E
FIG. 2
4. ADDRESS is now selected and should "blink". Using the UP/DOWN buton on the remote, step through the ADDRESS
until required ADDRESS to be changed is reached.
5. Press RIGHT/LEFT button to select DATA. When DATA is selected, it will "blink".
6. Again, step through the DATA using UP/DOWN button until required DATA value has been selected.
7. Pressing RIGHT/LEFT button will take you back to ADDRESS for further selection if necessary.
8. Repeat steps 4 to 6 until all data has been checked.
9. When satisfied correct DATA has been entered, turn POWER off (return to STANDBY MODE) to finish DATA input.
After the data input, set to the initializing of shipping.
10. Turn POWER on.
11. Press both VOL. DOWN button on the set and Channel button (1) on the remote control for more than 2 seconds.
12. After the finishing of the initializing of shipping, the unit will turn off automatically.
The unit will now have the correct DATA for the new MEMORY IC.
C-2
FUNCTION OF PCB
Y SUS
CTRL
50 SONY PSU
TDRV TOP
Z SUS
POWER
YDRV BOT
XRLT
50 SONY PSU
Y SUS
Z SUS
CTRL
XRLT
XRCT
XRRT
TDRV TOP
TDRV BOT
XRCT
XRRT
: A supplier which supplies voltage and current to each PCB and Panel.
: According to the timing provided from Panel Control, switches FETs and
generates driving waveform signal which is provided to Y electrode through
Scan Driver IC of TDRV TOP and TDRV BOT.
: According to the timing provided from Panel Control, switches FETs and
generates driving waveform signal which is provided to Z electrode through
Connector.
: Controls Y electrode, Z electrode, and ADDRESS electrode.
: Generates Address electrode and supplies to Address electrode by Driver IC.
: Generates Address electrode and supplies to Address electrode by Driver IC.
: Generates Address electrode and supplies to Address electrode by Driver IC.
: Generates Scan electrode and supplies to Y electrode by Driver IC.
: Generates Scan electrode and supplies to Y electrode by Driver IC.
C-3
ELECTRICAL ADJUSTMENTS
1. ADJUSTMENT PROCEDURE
NO.
01
02
03
04
05
06
07
08
09
10
11
12
13
14
15
16
17
18
Read and perform these adjustments when repairing the
circuits or replacing electrical parts or PCB assemblies.
CAUTION
• Use an isolation transformer when performing any
service on this chassis.
• When removing a PCB or related component, after
unfastening or changing a wire, be sure to put the wire
back in its original position.
• When you exchange IC and Transistor with a heat sink,
apply silicon grease on the contact section of the heat
sink. Before applying new silicon grease, remove all the
old silicon grease. (Old grease may cause damage to the
IC and Transistor).
Prepare the following measurement tools for electrical
adjustments.
FUNCTION
H POSI OSD
V POSI OSD
R DRIVE (N)
R CUT OFF (N)
G DRIVE (N)
G CUT OFF (N)
B DRIVE (N)
B CUT OFF (N)
R DRIVE (C)
R CUT OFF (C)
G DRIVE (C)
G CUT OFF (C)
B DRIVE (C)
B CUT OFF (C)
R DRIVE (W)
R CUT OFF (W)
G DRIVE (W)
G CUT OFF (W)
NO.
19
20
22
24
28
29
30
31
35
36
37
38
39
40
FUNCTION
B DRIVE (W)
B CUT OFF (W)
H POSI 60Hz
V POSI 60Hz
BRIGHT CENT
BRIGHT MAX
BRIGHT MIN
TINT
CONTRAST CENTER
CONTRAST MAX
CONTRAST MIN
COLOR CENT
COLOR MAX
COLOR MIN
Fig. 2-2
1. Pattern Generator
2-1: CONTRAST MAX
2. BASIC ADJUSTMENTS
1. Receive the monoscope pattern. (VIDEO Input)
2. Press the INPUT button on the remote control to set to the
AV mode.
3. Activate the adjustment mode display of Fig. 2-1 and press
the channel button (36) on the remote control to select
"CONTRAST MAX".
4. Press the VOL UP/DOWN button on the remote control
until the contrast step No. becomes "155".
5. Check if the picture is normal.
6. Receive the monoscope pattern. (RF Input)
7. Press the INPUT button on the remote control to set to the
TV mode.
8. Activate the adjustment mode display of Fig. 2-1 and press
the channel button (36) on the remote control to select
"CONTRAST MAX".
9. Press the VOL UP/DOWN button on the remote control
until the contrast step No. becomes "145".
10. Check if the picture is normal.
11. Receive the digital broadcast. (RF Input)
12. Perform the above adjustments 3 and 5.
13. Playback the DVD(480i) disc. (COMPONENT Input)
14. Press the INPUT button on the remote control to set to the
COMP mode.
15. Activate the adjustment mode display of Fig. 2-1 and press
the channel button (36) on the remote control to select
"CONTRAST MAX".
16. Press the VOL UP/DOWN button on the remote control
until the contrast step No. becomes "162".
17. Check if the picture is normal.
18. Playback the DVD(480i) disc. (HDMI Input)
19. Press the INPUT button on the remote control to set to the
HDMI mode.
20. Activate the adjustment mode display of Fig. 2-1 and press
the channel button (36) on the remote control to select
"CONTRAST MAX".
21. Press the VOL UP/DOWN button on the remote control
until the contrast step No. becomes "130".
22. Check if the picture is normal.
On-Screen Display Adjustment
1. Set the VOLUME to minimum.
2. Press the VOL. DOWN button on the set and the
channel button (9) on the remote control for more than
2 seconds to display adjustment mode on the screen as
shown in Fig. 2-1.
TV
AUTO
01 H POSI OSD
346
Fig. 2-1
3. Use the Channel UP/DOWN button or Channel button
(0-9) on the remote control to select the options shown
in Fig. 2-2.
4. Press the MENU button on the remote control to end
the adjustments.
5. To display the adjustment screen for AV, COMP, HDMI
and PC mode, press the INPUT button on the remote
control to set to the AV, COMP, HDMI and PC mode.
Press the VOL.DOWN button on the set and the
channel (9) on the remote control for more than 2
seconds.
D-1
ELECTRICAL ADJUSTMENTS
2-2: WHITE BALANCE
1. Place the set in Aging Test for more than 15 minutes.
2. Receive the gray scale pattern from the Pattern
Generator.
3. Press the INPUT button on the remote control to set to
the AV mode.
4. Using the remote control, set the brightness and contrast
to normal position.
5. Activate the adjustment mode display of Fig. 2-1 and
press the channel button (03) on the remote control to
select “R DRIVE (N)”.
6. Press the CH. UP/DOWN button on the remote control to
select the “R CUTOFF (N)”, “B.DRIVE(N)”, “B CUTOFF
(N)”, “R DRIVE (C)”, “R CUTOFF (C)”, “B.DRIVE(C)”, “B
CUTOFF (C)”, “R DRIVE (W)”, “R CUTOFF (W)”,
“B.DRIVE(W)”or “B CUTOFF (W)”.
7. Adjust the VOL. UP/DOWN button on the remote control
to whiten the R CUTOFF (N), B.DRIVE(N), B CUTOFF
(N), R DRIVE (C), R CUTOFF (C), B.DRIVE(C), B
CUTOFF (C), R DRIVE (W), R CUTOFF (W),
B.DRIVE(W) and B CUTOFF (W) at each step tone
sections equally.
8. Perform the above adjustments 6 and 7 until the white
color is looked like a white.
2-3: BRIGHT CENT
1. Receive the monoscope pattern. (VIDEO Input)
2. Press the INPUT button on the remote control to set to
the AV mode.
3. Set the screen mode to FULL.
4. Using the remote control, set the brightness and contrast
to normal position.
5. Activate the adjustment mode display of Fig. 2-1 and
press the channel button (28) on the remote control to
select "BRIGHT CENT".
6. Press the VOL. UP/DOWN button on the remote control
until the white 8.1% is starting to be visible.
7. Receive the monoscope pattern. (RF Input)
8. Press the INPUT button on the remote control to set to
the TV mode. Then perform the above adjustments 4~6.
9. Receive the digital broadcast. (RF Input)
10. Perform the above adjustments 4~6.
11. Playback the DVD(480i) disc. (COMPONENT Input)
12. Press the INPUT button on the remote control to set to
the YUV mode. Then perform the above adjustments
4~6.
13. Playback the DVD(480i) disc. (HDMI Input)
14. Press the INPUT button on the remote control to set to
the HDMI mode. Then perform the above adjustments
4~6.
D-2
ELECTRICAL ADJUSTMENTS
2-4: Confirmation of Fixed Value (Step No.)
Please check if the fixed values of each the adjustment items are set correctly referring below. (TV/AV/COMPONENT/HDMI/PC)
AV
HD-MI
COMPONENT
PC
VGA
TV
CVBS
NO.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
22
24
28
29
30
31
35
36
37
38
39
40
FUNCTION
H POSI OSD
V POSI OSD
R DRIVE (N)
R CUT OFF (N)
G DRIVE (N)
G CUT OFF (N)
B DRIVE (N)
B CUT OFF (N)
R DRIVE (C)
R CUT OFF (C)
G DRIVE (C)
G CUT OFF (C)
B DRIVE (C)
B CUT OFF (C)
R DRIVE (W)
R CUT OFF (W)
G DRIVE (W)
G CUT OFF (W)
B DRIVE (W)
B CUT OFF (W)
H POSI 60Hz
V POSI 60Hz
BRIGHT CENT
BRIGHT MAX
BRIGHT MIN
TINT
CONTRAST CENTER
CONTRAST MAX
CONTRAST MIN
COLOR CENT
COLOR MAX
COLOR MIN
D-3
346
88
127
133
128
128
129
131
125
132
128
128
132
130
131
130
128
128
121
130
280
26
107
185
60
117
128
145
70
80
180
0
346
88
127
133
128
128
129
131
125
132
128
128
132
130
131
130
128
128
121
130
280
26
107
185
60
117
128
145
70
80
180
0
S(Y/C)
346
88
127
133
128
128
129
131
125
132
128
128
132
130
131
130
128
128
121
130
280
26
107
185
60
117
128
145
70
80
180
0
480i
346
88
127
133
128
128
129
131
125
132
128
128
132
130
131
130
128
128
121
130
282
26
107
185
60
121
128
162
70
106
180
0
480p
346
88
127
133
128
128
129
131
125
132
128
128
132
130
131
130
128
128
121
130
140
30
115
185
60
126
128
155
70
56
180
0
720p
346
88
127
133
128
128
129
131
125
132
128
128
132
130
131
130
128
128
121
130
312
26
115
185
60
126
128
155
70
56
180
0
1080i
346
88
127
133
128
128
129
131
125
132
128
128
132
130
131
130
128
128
121
130
260
26
115
185
60
126
128
155
70
56
180
0
480i
346
88
127
133
128
128
129
131
125
132
128
128
132
130
131
130
128
128
121
130
284
26
95
185
60
123
128
130
70
78
180
0
480p
720p
1080i
VGA
60*480
346
88
127
133
128
128
129
131
125
132
128
128
132
130
131
130
128
128
121
130
142
26
95
185
60
123
128
130
70
78
180
0
Step No.
346
88
127
133
128
128
129
131
125
132
128
128
132
130
131
130
128
128
121
130
278
24
95
185
60
123
128
130
70
78
180
0
346
88
127
133
128
128
129
131
125
132
128
128
132
130
131
130
128
128
121
130
214
24
95
185
60
123
128
130
70
78
180
0
346
88
127
133
128
128
129
131
125
132
128
128
132
130
131
130
128
128
121
130
142
26
95
140
60
123
128
130
70
78
180
0
346
88
128
...
128
...
128
...
...
...
...
...
...
...
...
...
...
...
...
...
110
26
103
140
30
...
80
100
64
...
...
...
SVGA
XGA
WVGA
WXGA
WXGA
800*600 1024*768 1280*768 1280*720 848*480 1360*768
346
88
128
...
128
...
128
...
...
...
...
...
...
...
...
...
...
...
...
...
88
24
103
140
30
...
80
100
64
...
...
...
346
88
128
...
128
...
128
...
...
...
...
...
...
...
...
...
...
...
...
...
230
26
103
140
30
...
80
100
64
...
...
...
346
88
128
...
128
...
128
...
...
...
...
...
...
...
...
...
...
...
...
...
190
19
103
140
30
...
80
100
64
...
...
...
346
88
128
...
128
...
128
...
...
...
...
...
...
...
...
...
...
...
...
...
190
18
103
140
30
...
80
100
64
...
...
...
346
88
128
...
128
...
128
...
...
...
...
...
...
...
...
...
...
...
...
...
110
26
103
140
30
...
80
100
64
...
...
...
346
88
128
...
128
...
128
...
...
...
...
...
...
...
...
...
...
...
...
...
366
16
103
140
30
...
80
100
64
...
...
...
D-4
ELECTRICAL ADJUSTMENTS
3. ELECTRICAL ADJUSTMENT PARTS LOCATION GUIDE (WIRING CONNECTION)
PDP PANEL
SPEAKER
CP3807
CD4203
CP802
CP803
J4211
J4204
SCALER PCB
AV PCB
SIDE JACK PCB
OS2251
CP2251
J4209
CP4200
REMOCON PCB
J4208
J4207
J4206
CP2203
CP3901
OPERATION PCB
CP3900
FILTER PCB
CD3810
AC IN
D-5
J3601
J4205
CP3603
CP4302
CP3601
CD4204
CP7202
J4301
J2275
J4201
CP901
CP2200
CP3602
TU5800
CP3201
CP4202
CP4204 CP4203
CP301
CP303
CP4201
CP3804
CP3801 CP3803
CP3802
SPEAKER
TROUBLESHOOTING GUIDE
POWER DOES NOT TURN ON
IS F3900 BROKEN ?
YES
CHANGE F3900.
NO
IS THERE VOLTAGE
AT PIN 11 OF CP3201
5V ?
NO
CHECK CP3201 AND
CP3804.
NO
CHECK IC3804 AND
PERIPHERAL CIRCUIT.
OR CHANGE AV PCB.
YES
IS THERE VOLTAGE
AT PIN 2 OF IC3804
AT3.3V ?
YES
CHANGE SCALER PCB.
E-1
TROUBLESHOOTING GUIDE
THE PICTURE DOES NOT
APPEAR (1).
IS CD7206 CONNECTED ?
NO
CONNECT CP7202.
YES
IS THERE SIGNAL
AT IC7202 ?
NO
CHANGE IC7202.
YES
IS THERE SIGNAL
AT IC7501 ?
NO
CHANGE IC7501.
YES
CHECK IC801.
OR CHANGE SCALER PCB.
E-2
TROUBLESHOOTING GUIDE
THE PICTURE DOES NOT
APPEAR (2).
IS THERE SIGNAL
AT IC4201 ?
NO
CHECK IC4201 AND
PERIPHERAL CIRCUIT.
NO
CONNECT CD4203.
CHECK IC4201 AND
PERIPHERAL CIRCUIT.
YES
IS CD4203 CONNECTED
AND IS THERE SIGNAL ?
YES
CHECK IC801 AND
PERIPHERAL CIRCUIT.
E-3
TROUBLESHOOTING GUIDE
THE PICTURE APPEARS, BUT
THE AUDIO DOES NOT
APPEAR.
IS CD301 AND CD303
CONNECTED ?
NO
CONNECT CD301 AND CD303.
YES
IS THERE SIGNAL
CD301 AND CD303 ?
YES
CHANGE SP301 AND SP302.
NO
IS THERE SIGNAL
AT PINS 11 AND 15
OF IC301 ?
YES
CHECK IC301 AND
PERIPHERAL CIRCUIT.
NO
IS THERE SIGNAL
AT PINS 27 AND 28
OF IC904 ?
NO
CHECK IC904 AND
PERIPHERAL CIRCUIT.
YES
CHANGE AV PCB.
E-4
TROUBLESHOOTING GUIDE
THE COLOR DOES NOT
APPEAR.
IS SETTING OF
COLOR NORMAL ?
NO
CHANGE THE SETTING OF
COLOR.
YES
IS THE COLOR
SIGNAL RECEIVED ?
NO
RECEIVE THE COLOR SIGNAL.
YES
IS THERE SIGNAL
AT IC801 ?
NO
CHECK IC801 AND
PERIPHERAL CIRCUIT.
NO
CHECK IC2101 AND
PERIPHERAL CIRCUIT.
YES
IS THERE SIGNAL
AT IC2101 ?
YES
CHANGE SCALER PCB.
E-5
TROUBLESHOOTING GUIDE
ON SCREEN DISPLAY DOES
NOT APPEAR.
IS THERE SIGNAL AT
PINS 2, 3, 4 AND 5 OF
IC101 ?
NO
CHECK IC101 AND
PERIPHERAL CIRCUIT.
YES
IS THE COLOR SIGNAL
AT PINS 57, 58, 59 AND
60 OF IC801 ?
NO
CHECK IC801 AND
PERIPHERAL CIRCUIT.
YES
CHANGE SCALER PCB.
E-6
SCALER/LVDS/MICON/ADC/VIDEO ENHANCER/REGULATOR BLOCK DIAGRAM
VIDEO ENHANCER
IC7501
DV1000-75
DIGITAL RGB
INTERFACE
DDVS
64
DDHS
66
DIGITAL
24bit RGB
DDHS, DDVS, DDCK
A/D CONVERTER
IC2101
67 MST9883C-LF-110
DDCK
VGA_HS
VGA_VS
30
56
31
57
DIGITAL
24bit RGB
DCLK2,DHS,DVS,DEN
13
42
31
SCALER
IC801
R8J66607A72FP
DIGITAL 24bit RGB
DHS1,DVS1,DENO
LVDS IC
IC7202
ICSV385AGLFT
84
X801
54MHz
54 48 43
TX OUT0~3+
TX OUT0~3TXCLKOUT+
TXCLKOUT-
PDP PANEL
V801
PDP50X3
85
33 44 21
57
60
SW_CVBS
SW_Y
SW_C
EEPROM IC 256K
IC103
AT24C256N-10SU-2.7
4SI_SDA_IN/4SI_SCL
4SI_CHIP_SE/4SI_SDA_OUT
SCART1_B_IN
AV SWITCH/AV
SWITCH2/AV
JACK/STEREO/
SOUND AMP/
JACK
SCART1_G_IN
6
EEP_SCL
5
EEP_SDA
SCART1_R_IN
EEPROM IC 256K
IC104
AT24C256N-10SU-2.7
2
AUDIO_MUTE
58
SCL
27
SDA
28
6
4
SCART2 OUT CVBS SW
IC8103
MM1501XNRE
MICON
IC101
OEC7164A
5
54
6
EEP_SCL
53
5
EEP_SDA
POWER_ON-H
18
1
2
74 90 17 89 10 76 16
PSU_5VD
TUNER/DIGITAL/
POWER
LCD_H
POWER_FAIL
OS2251
LCD_ON
1
2
SYSTEM RESET
IC102
PST3229NR
1
3
RESET
AT+3.3V
P.CON+3.3V REG
IC3201
BA00BC0WFP-E2
D105
2
1
SCALER_H
4
P.CON+3.8V
P.CON+3.3V
P.CON+1.5V REG
IC3202
BD7820FP-E2
2
1
4
OPE AMP
IC2275
NJM4580V (TE1)
3
IR PASS THROUGH
J2275
7
Q2275~Q2277
2 L
SW
3 R
P.CON+1.5V
P.CON+1.8V REG
IC3203
BD7820FP-E2
2
1
4
P.CON+1.8V
F-1
F-2
AV SWITCH/AV SWITCH2/AV JACK/STEREO/SOUND AMP/JACK BLOCK DIAGRAM
AV SW
IC4201 AN15853B-E1
YELLOW
J4207
WHITE
J4208
RED
J4209
2
2
2
18 SIDE_V_IN
15 SIDE_A_IN_L
17 SIDE_A_IN_R
INPUT 1/2
J4205
AV1_IN
2
14
S1_Y_IN
4
3
S1_C_IN
6
4
AV1_A_IN_L
3
17
AV1_A_IN_R
S_VIDEO JACK
J4206
20
11 SIDE_Y_IN
S2_Y_IN
20
9
4
13 SIDE_C_IN
S2_C_IN
22
10
AV2_IN
25 SCL
SCL
TUNER/POWER
5
3
24 SDA
SCA
9
15
YUV1_A_IN_R 12
18
YUV1_A_IN_L
22
28 SW_A_R
10
AUDIO_IN 4/5
J4204
30 SW_A_L
SCALER/LVDS/
MICON/ADC/VIDEO
ENHANCER/
REGULATOR
31 SW_CVBS
SW_CVBS
SW_Y
33 SW_Y
SW_C
35 SW_C
5
2
16 TUNER_V
PC AUDIO IN
J4301
YUV2_A_IN_L 19
PC_A_IN_L
4
HDMI AUDIO IN
J3601
2
DVI_A_IN_R 3
7
COMPONENT SW
IC4204
NJM2584AM(TE1)
STEREO
IC904 MSP4440G-QA-C13-100
PC_A_IN_R 2
DVI_A_IN_L
3
YUV2_A_IN_R 21
56 SW_A_IN_L
5
3
7
YUV/HDMI/DVI Lch SW
IC4304 NJM2534V (TE2)
AV2_A_IN_L
53 SW2_A_IN_L
7
54 SW2_A_IN_R
XTAL_IN
SW
IC8104
NJM2584AM(TE1)
71
X901
18.432MHz
XTAL_OUT
SCL
2
I2C_CL
SDA
3
I2C_DA
2
36
VARIOUT_R
3
37
VARIOUT_L
AUDIO_MUTE
6
AV2_A_IN_R 51
3
SCALER/LVDS/
MICON/ADC/VIDEO
ENHANCER/
REGULATOR
5
50
72
Y
14 U
V
1
Y
8
11 U
3
57 SW_A_IN_R
YUV/HDMI/DVI Rch SW
IC4305 NJM2534V (TE2)
5
9
16
V
CS_IN 4/5
J4211
2
5
8
3
6
9
9
5
SCART1_R_IN
1
6
SCART1_G_IN
3
SCART1_B_IN
14
11
8 16
5
SIF
SIF 67
SOUND AMP
IC301 TA2024-ASE
AUDIO_OUT_JACK
J4201
MICON2
HDMI_I2SSCK
4
I2S_CL
SPOUT_R
27
15 INV2
3
HDMI_I2SSDO
7
I2S_DA_IN1
SPOUT_L
28
11 INV1
2
HDMI_I2SWS
5
I2S_WS
VGA_G
VGA_R
TUNER/
POWER
SOUND+B
INTERFACE
33 VDDA
SPEAKER
SP304
30 VDD1
TUNER_VIDEO
TUNER/POWER
VGA_B
CP901
4
SCALER/LVDS/
MICON/ADC/VIDEO
ENHANCER/
REGULATOR
12 MUTE
OUTP1 31
29 VDD1
OUTM1
26 VDD2
OUTM2 27
25 VDD2
OUTP2 24
28
SPEAKER
SP302
SPEAKER
SP301
SPEAKER
SP303
F-3
F-4
TUNER/POWER BLOCK DIAGRAM
SCL
V_OUT
SIF OUT
3 15
11 10
17
14
SDA
+B
+32V
TU5800
SCL
SDA
TUNER VIDEO
AV SWITCH/
AV SWITCH2/
AV JACK/STEREO/
SOUND AMP/JACK
SIF
DC-DC CONVERTER
IC3803
BD9300FV-E2
CP3801
1
SOUND+B
2
SOUND+B
SOUND+B
8
5
CP3803
1
2
AT+3.3V REG
IC3804
PQ070XF01SZH
1
5VSC
2
5VSC
AT+3.3V
3
5VSC
AT+5V
7
12VSC
8
12VSC
AV SWITCH/
AV SWITCH2/AV JACK/
STEREO/
SOUND AMP/JACK
P.CON+12V
P.CON32V REG
IC3805
LA7995M-TLM
CP3802
1
9VSC
1
POWER FAIL
2
LCD_H
3
AT+5V
5
LCD_ON
6
5VD
SCALER/LVDS/
MICON/ADC/ADC2/
AV SWITCH1/
REGULATOR
14
P.CON+3.8V
IC3808
BA7810T-V5
CP3804
2
7
4
P.CON+3.8V
P.CON+9V
PSU_5VD
LCD_ON
LCD_H
POWER_FAIL
F-5
F-6
INTERFACE BLOCK DIAGRAM
EEP_ROM
IC3606 BR24L02F-WE2
6 SCL
7 WP
7 WP
8
Q3615
Q3616
BUFFER
Q3603
BUFFER
Q3604
BUFFER
Q3619
19 DET
18 POWER
29 DSDA1
30 DSCL1
2
3
32 DSCL0
Q7
133
Q6
136
Q5
137
Q4
140
Q0
144
39 R0XC-
L3603
ACM2012D-900-2P
1
2
L3602
ACM2012D-900-2P
HDMI
CONNECTOR
CP3603
19 DET
18 POWER
16 SDA
15 SCL
12 CLK10 CLK+
9 D07 D0+
6 D14 D1+
3 D21 D2+
1
4
2
3
4
3
L3604
ACM2012D-900-2P
Q12 126
129
SW
4
119
Q15 123
Q11
L3601
ACM2012D-900-2P
1
113
31 DSDA0
Q3613
SW
16 SDA
15 SCL
12 CLK10 CLK+
9 D07 D0+
6 D14 D1+
3 D21 D2+
Q20
Q16
BUFFER
HDMI
CONNECTOR
CP3601
110
Q19 116
8 VCC
VCC
Q23
40 R0XC+
HSYNC
DDHS
VSYNC
3
DDVS
SCK
86
WS
85
47 R0X1-
SD0
84
48 R0X1+
OVCC
5
OVCC
6
43 R0X044 R0X0+
1
51 R0X2-
OVCC 26
2
L3608
ACM2012D-900-2P
3
52 R0X2+
OVCC 76
1
4
3
1
2
L3606
ACM2012D-900-2P
1
4
2
3
OVCC 89
L3607
ACM2012D-900-2P
4
3
DDCK
2
4
2
DIGITAL RGB
ODCK 121
58 R1XC-
OVCC 109
59 R1XC+
OVCC 122
1
4
OVCC 134
62 R1X0-
CSCL
63 R1X0+
CSDA 27
28
1.8VREG
IC3601 BD7820FP-E2
DDVS
1
4
WS
RESET# 102
L3605
ACM2012D-900-2P
66 R1X1-
INT 104
67 R1X1+
VCC 105
DVCC2 94
SCK
SDO
1
4
70 R1X2-
VCC 92
CSCL
2
3
71 R1X2+
VCC 79
CSDA
D-SUB
CP4302
SCALER/LVDS/
MICON/ADC/VIDEO
ENHANCER/
REGULATOR
3.3VREG
IC3602 BA00BC0WFP-E2
OUT
6 SCL
OUT
5 SDA
IN
5 SDA
HDMI INTERFACE
IC3605 SII9021CTU
IN
EEP_ROM
IC3609 BR24L02F-WE2
MICON2
DVCC 74
1 VGA-R
2 VGA-G
3 VGA-B
13 VGAHS
VGA-R
VGA-G
VGA-B
VGA_HS
14 VGAVS
VGA_VS
AV SWITCH/AV
SWITCH2/AV JACK/
STEREO/SOUND
AMP/JACK
SCALER/LVDS/
MICON/ADC/VIDEO
ENHANCER/
REGULATOR
VCC 114
VCC 128
RXT_RST#
H_INT
VCC 139
DACDVCC 22
VCC 23
VCC 35
F-7
F-8
MICON2 BLOCK DIAGRAM
HDMI MICON IC
IC3611
SST89E58RD2-40-C-TQJE
36 RX1_RST
RXT_RST#
8 RX1_INT
H_INT
X1 15
X2 14
X3601
11.0592MHz
38 VCC
29
CSDA
Q3606
BUFFER
EA-/VPP
V-SYNC 41
Q3620
LEVEL SHIFT
DDVS
INTERFACE
3 CSDA
EEP ROM IC
IC3608
BR24L32F-WE2
3 A2
INTERFACE
CSCL
VCC
8
WP
7
SCL
6
SDA
5
2
CSCL
Q3605
BUFFER
WS
DSO
SCK
CP3602
AV SWITCH/AV
SWITCH2/AV
JACK/STEREO/
SOUND AMP/
JACK
F-9
4
3
HDMI_I2SSC
K
HDMI_I2SSDO
2
HDMI_I2SWS
F-10
D2275
G-1
R2280
Q2275
C2280
R2278
C2278
IC2275
R2287
R2285
J2275
J4201_1
C2277 R2279
L4218
L4219
L4212
J4205
D4207
L4214
D4206
J4211
CP4201
C304
Q4402
W876
CP4204
W839
D901
R4231
C365
C364
R311
L3804
L3801
L3803
C3802
Q3804
R4233 Q4208
Q4210
C4264_1
R4234
R3801
R3805
R3806
R4401
R4402
L3810
C3801
L3805
C3823
W870
L3802
R3808
W835
W821
C2252
CP3804
CP4203
C5815
R4230
R325
Q4403
C3805
C3803
C3817
R3822
NTSC
C4252
L4204
R4223
R4410 C4265_1
C3830
Q301
C3836
L4203
C3833
L4206
C3829
R4409
C4256
C3832
C904
4
Q302
CMF091A
L5801
C5812
TOP\\REFLOW
D3805
C3848
D3804
Q300
R5803
R5802
C5807 C5809
C3834
C3837
C4202 C4239
C4201 C4238
CP3802
C4260
C4261
L5800
C906
L901
C3827
R324
IC3804
C4232
R3855
C3820_1
C3821
R3825
D3803
C3849
D2252
CP3803
L4207
IC4201
TU5800
D4208
D4212 C4416 C4251 D4210
C4250
C4415
C4243
C4203
L4202
C4242
C319
C961
W856
W857
C960
C320
W890
L4403
C4214
C4230
C4246
R4209
R4212
C915
C918
HS300
L4217
C4233
D4211 C4205
C4220
C4218
C4207
C4224
C4206 C4222 C4227
C4223
C4217
L4216
STEREO
L4215
C4229_1
C4215
C953
C955
L4213
B4215
B4216
C914
SOUND
C4464
41
IC4204
25
C963 C962
IC904
R4261
1
C4296
R4254
C927
C946
C3826_2
L3809
C3825_2
L3808
HS3801
C4449
CP901
C922
65
C4297
R4252
C948
R903
R902
C952
C950
L903
C951
L904
IC3808
C4453
R4236
R4235
C933
X901
W848
CP2251
C919
C941
R905
R906
C949
S801X
C4273
R2252
C916
W894
D4205
R4245
L4211
R2259
C4452
Q4207
C3839
R3824
C4451
Q4201
W893
L301
C4279
L2275
C323
C332
R319
W892
C328
C2282
Q2252
R4241
C326
S801Y
R318
C331
R317
C324
C2255_1
4
C4450
L300
W911
W910
IC301
L303
R2257
C2256
Q2251
W919
Q3808
C4448
Q4209
R4229
R321
R4232
C341
W889
W917
OS2251
CP3801
C5803
L4221
W884
C339
CP301
CP303
D2251
L4220
C340_2
L302
C342_2
R2256
C337
C2276
R2282
R2281 C2279
R320
PRINTED CIRCUIT BOARDS
AV/REMOCON (TOP SIDE)
CEF211A
W945
CP4202_1
R3802
Q3805
D4209
CP3807
C3835
TUNER
C4247
W869
C2275
J4204
JACK
G-2
G-3
R2276
W907
Q2277
C352
C363
C349
C348
D302
R2283
R2275
C2281
R2277
R2288
B2271
R4263
B4206
C338
D303
C301
C354
C350
D304
R315
D305
C2283
R2289
C4300 R4237
R4238
C4301
Q4200
R314
C4272
Q4211
R338
R4243
C4275
C956 C957
C944
C355
C351
C359
C362
C353
C358
C959
R3858
R3857
R2253
R3830
C3819
R3856
R3823
R3821
R3820 C3816
R2255
R2254
C3822
IC3803
R4247
R4239
C943
C945
C954
C940
C942
R304
C3847
R3826
R3833
W836
C4271 C4274 R4246
R4244
B906
W920
B904
R904
R916
C936
R302
W842
Q3806
B4214
B4221
R4251
C958
Q3802
R3828
R4248
C4277
B4222
C934
C926
C920
D3809
Q4233
B4217
R4240
R4255
R4298
C4454
B4219
R4253 R4250
C4455 C4288
R4295
C917
R3834 R3835
R3831
C3806
C3804
R914
Q3801
R4249
C4283
R4272
R4262
R4297
R4296
D4202
C4225
C4208
Q902
B4211
C4278
C4258
B4220
R4259
B4205
C4284
W865
W867
C4456
C4221
D4203
C4216 C4228
R4219
R4220
R913
C4413
R3803
R4269
R4271
R4268
R4294
R4299
C4226
C4210
C5802
W886
C3828
C3831
R4257
W802
CMF091A
R4270
R4267
B4204
R4260
R4242
C4276
B4218
C4282
R4211
C4211
C4231
R4216
C4292
W844
C5811
B5801 C5810
R322
D306
R4420
R323
C4285
C4213
Q4205
R5800
W928 Q4206
C5806
R5801
R5805
W852
R4415
C4287
Q4203
C4240
R4228
Q901
C4289
B5802
R4213
R4210
R4225
W929
Q4231
C4290
C5801
C5804
C4267
R4214
R3832
C4414
PRINTED CIRCUIT BOARDS
AV/REMOCON (BOTTOM SIDE)
CEF211A
Q3807
CD804
R3827
R915
IC3805
R2284
Q2276
R2286
G-4
G-7
CP3201
B3207
W857
R148
R118
R147
R129
R146
R126
R122 R123
R121 R120
R119 R134
LVDS
IC104
CP7202
R151
R173
R174
W990 C109
X101
R128
26
R145
IC101
51
CP103
D109
CP102
R149
D105 R114
R115
CP802
W981
C801
R8124
1
76
CP101
C128
C110
R2115
W1018
IC2101
W823
W874
W985
NR2101 NR2102NR2103 NR2104
C101
NR807 NR806 NR805 NR804 NR803 NR802
C2127
41
W1016
1
W1017
C2121
61
R164 W907
W967
C815
C2103
R2109
C2133
C2802
W877
W982
R8122
MICON
IC3202
L2103
C2139
D4302
R7505
C2149
Q2101
R2112
C4378
3
C883
C830
L8105
CP803
C8149
C8126
C8122
W1014 W964
C8151
AV_SW
D4301
C891
C892
L8104
C4372
R833
C8120
C8121
C8131
W900
C116
163
W963
Q105 Q101
109
W843
C8123
W944
W972
R163
R127 R110
IC801
C131
C858
C2130
W1025
C2106
1
C136
55
NR2105 NR2106
D802
IC102
CEF156A
C832
C834
D.COMB
C125
NR7501NR7502
D803
C863 C860 C857
SCALER
R135
D3206
D805
C7209
W905
C868
C859
W968
IC103
C7503
C876
1
C7219
1
C810
R3652
C4362
C3600
C8124
C8125
C4328
C4337
C4366
R4315 R4310R4316
R4305 R4309
B4304
B4303
R4308
R189
97
B4308 C4315 R4314
C4314
R4313
C7208
IC3608
NR801
C4324
L4306
R3600
D3603
D3601
R3601
L3601
L3603
L3602
L3604
B4307
Q3613
C2801
33
R825 C861
C7518
R830
L3623
NR3606 NR3605 NR3604 NR3603
C3687
C3685 R3638
C3648_1
J4301
B801
B804
65
C850
C7238
C7239
C7240
C7241
C7242
R7507
C7519
X3601
C3654
C3686
R3633
B3622 C3650
R3687
R3684
D3626
D3627
R3610
C3633
D3602
L3608
L3607
L3606
L3605
C3604
CP3601
R7201
D3207
X801
IC3611
C856
R3648
X7501
R3632
C3643
R3619 C3642
R3718
D3613
C3611
MICON2
R7513
Q3605
C7521
R3631
R3649
R3714
R3713
R3716
Q3619
C3722
C898
CP3604
C3637
C3632
R3651 R3622
IC3605
R3712
R3621
C7203
IC3201
C3224
W859
Q3606
R3639
R3647
X3602
R3697
C3694
R3698 C3693
37
NR7503
NR7504
C3640
R3628
C3702
R3679
R3680
IC7501
NTSC/PAL
R3640
C3639
D3609
R3645
R3637
R3717
C3723
R3641
R3643 W969
R3644 W970
C3659
C3615
C3634
C3658
C3703
109
C3638
C3641
R3627
C3705
73
W957
DAC/AMP
Q3620
C3707
J3601
R141 R142
POWER
R188
C3217
C3213
B3612 W1024 B3606
CP3602
R3626
R3625
B3206
B3203
B3202
B3205
B3201
R3224
R3223
Q3205
W860
PRINTED CIRCUIT BOARDS
SCALER (TOP SIDE)
CP3603
CP4302
R4304
R4323
B4305
JACK
C8150
R2114
R8105
21
R208
W984
W820
C117
CP2200
G-8
G-7
C123
R131
R133
R132
Q104 Q106
R136
IC7202
IC3203
R3237
D3212
C7506
C7507
D3208
W973
W872
R7510
R7509
C7514
C7513
C7515
C7512
W975 C7516
W803
W883
C3646
C3647
R3245
Q3211
R3705
R3238
C3219
C3218
C3649
R3706
C3645 R3708 R3707
C3653
B3613
C3635
R3704
C3618
C3626 C3620
C3711
R3701
R3702
C3710
R3703
R3689 B3605
C3709
C3708
C3712
C3704
IC3602
D3628
D3629
C3627
B3603
C3657
C3719
C3610
C3625
C3651
W1023 W1022R3634
R3654
IC3601
C3713
B3621
C3652
Q3614
R3681
R3653
R8115
R8119
C8128
R8113 R8116 L8102
C8129
C8137
R8114
R3686 R3683
R3635
Q3621
D3600
D3605
C3609
C4353
C4352
C4351
R3630
R3606 R3607
R3688
R3605
D3630
R4333
L4301
R4329
R4328
R4319
R4324
C3606
C4358
R3693 R3694 R3692
C4357
W852
C3602
R3709
C3621
C3720 C3721
R3695 R3711 C3622
R3710
C3623
C3656
C3688
R3690
C3624 C3607
C3628 C3605
D3604
C3630
C3655
C3689
C3612
C3690
C3717
C3718
C3617
C3714
C3608
C3715
C3716
C3619
C3616
R3669
R3617
C3706
W839
B7502
W930
W929
C8110
C8113
C8109
C8112
IC8103
IC4305
R3685
W1007 R3228
C3212
C3211
R3211
R3212
R3220
R3217
C7504
R3235 R3234
C3223
R3232 C3222
W989
R3221
R3222
W1010
D3209
W974
C7509
W869
W854
W870 B7501
W871
R836
C7508
C862
C4350
Q3206
W830
NR7506 NR7505
R3216
C7218
C855 C852
B806
C820
C3216
C3215
C896 R834 R835
C7510
R844
R845
R821 R826
C870
R822 R828
C872
R829 C879
C875
C897
C895 C821
C884
C888
C887
W807
IC4304
Q3615
C3204
NR7203 NR7204
R807
W805
C2151
C2150
C8147
R8130
R8128
R8129
R8131 C8146 C8144
R8125
R8123
R8146 R8148
R8143 R8145
IC8104
Q3604
C3206
C7226
R804
W988
R3236
C871
C849
Q4302
IC3606
C3207
R198
C886
R819 R820
W809
R4320
C3205
C126
R817 R818
C7221
R831
Q4305
R3244
R3246
R140
C877 C873
C878
W801
R823
B2101
C894
C813
R2104
C889
C853
C7227
R117
B802
R7206
C2110
C2108
W931
W802
C824
C836 C838 C837
C823 C814
C839
C840 C841 C816 C812
C826
C842
C843 C817
C844
C847 C845 C818
C835
C846
C819
C827
L2107
C893
NR3602
C822
C851
C2125
B803
R2111
C2144
NR3601
W882 C7222
C7229
R2106
W810
C2136
C2137
W978 W821
W892
Q3603
C3203
C3201
R158
Q8103
R7207
C104
Q8102
R7210
R138
Q8101
B7202
B805
C2111
R8118
C7202
R116
L7202
C2109
R8121
W889
W835
W834
R7211
W880
C2112
R8117
L7201
D808
L7203
C2113
C2131
C2120
R2103
C2116
R2102
C2105
L2101
C2124
C2126
R2108
R2110
C2129
C2138
C2143
C2132
C2145 L2106
L2102
W979
Q8105 Q8106
R8120
C7201
R178
W983
W891
R3608 R3609
W1013
C106
R209
D807
W987
W971
CEF156A
R181
W1015
R192
R193
R107
R109
C118
R137
R175
R204
R205
R102
R105
R106
C113
C111 C114
R195
R176
R177
R104 R103
R194
W980
R200
W897
W895
W896
R154
R157
R156
R155
C107
R199
R161 R160
C3629_1
PRINTED CIRCUIT BOARDS
SCALER (BOTTOM SIDE)
B3601
Q3616
B3602
IC3609
Q3618
C3613
C3614
C3691
C3699
Q3617
R3629
R3696
Q3607
C3700 C3692
R3678 C3696 C3695
C3697 C3698
R3699
C3701
R3700
W1012
B3604
L7502
C7511 R7508
R7506 R7512
C7505
C7502
R3209
Q3210
G-8
PRINTED CIRCUIT BOARDS
OPERATION
FILTER
SIDER JACK (INSERTED PARTS)
SOLDER SIDE
SOLDER SIDE
SOLDER SDIDE
J4209
J4208
J4206
J4207
FH3900
L4200
L4227
W894
D3900
RISK OF FIRE
- REPLACE
AS MARKED .
CP3900
CP4200
F3900
W862
FH3901
CEF210A
W860
W859
SW2205
CEE131A
D3902
SW2201
PH3901
D3901
CP3901
SIDER JACK (CHIP MOUNTED PARTS)
SW2203
R2205
CEE133A
PH3900
SOLDER SDIDE
W856
W855
SW2202
B4208
R6504
R6505
R2204
R2206
C6542
W857
C6543
R2203
SW2204
W858
R4493
R2202
R6508B4210
R6506
R6509 B4209
D2202
C2209_1
CEF210A
R2201
W899
SW2206
C2204_1
G-9
D2203
CP2203
G-10
A
B
C
D
E
F
G
H
AV SWITCH2 SCHEMATIC DIAGRAM
(AV PCB)
8
TR4205
ZCAT3035-1330
TR4201
W5T29X7.5X19
FROM POWER
8
TR4203
ZCAT2436-1330A
TR4202
W5T29X7.5X19
TR4205
ZCAT3035-1330
TR3806
ZCAT2436-1330A
TR3805
ZCAT3035-1330
TR4204
W5T29X7.5X19
AT+3.3V
AT+5V
P.CON+9V
GND
P.CON+5V
FROM OPERATION/FILTER
7
7
CP4201
A2001WV2-8P
SIDE_S_SW
W869
47uH 0305
L4202
SIDE_V_IN
1
SCL
SDA
IR-THROUGH
S2_Y_IN
S_SW_2
YUV2_A_IN_L
C4415
GND
2
REMOCON IN
1
IR-THROUGH
19
56
R4234
2.7K
R4231
G
S
D
S
D
G
27
NC
Q4208
KTK5132E
B
22
DTUNER_RESET_L21
20
18
NC SC2_AUDIO_OUT-H16
0.1
C4265_1
B
0.1
C4264_1
25V 100 YK
C4261
C4260
23
SW_AUDIO_L(PC)17
STEREO_RESET
STEREO_RESET 15
NC
SCART3_SW 14
NC
SCART_AUDIO_SW13
SDA1
SCL1
12
GND
10
10
DTUNER_POWER9
NC
DTUNER_SD_H 7
GND
8
6
SWITCH_CVBS 5
SWITCH_VIDEO_Y 3
GND
R4228
390
GND
3
11
NC
GND
25V
W929
1K
24
CH
R4410
1.5
W928
2.1
C4256
BUFFER
Q4206
KTC3875S_Y_RTK
8.9
1K
25V 100 YK
1.5
25
SW_AUDIO_R(PC) 19
YK
820
R4409
CH
R4223
BUFFER
Q4205
KTC3875S_Y_RTK
R4225
AV SW IC
AN15853B-E1
1.8
DTUNER_TX
GND
4
2
2
SWITCH_VIDEO_C 1
390
L4203
BUFFER
Q4203
KTC3875S_Y_RTK
C4252
8.9
2.4
8.9
2.1
C4292
10P
0.01 B
C4240
DTUNER_RX
GND
33uH
4
GND/INV_DET 26
NC
GND
CD4203
2H0T0801
4.9
SW
Q4231
0
KRA103SRTK
SW
Q4233
0 KRC102SRTK
DTV_MUTE_L
LEVEL SHIFT
47uH 0305
390
C4247
NC
56
R4233
R4230
23
24
25
L4204
W802
B
28
NC
GND
16V 22 KA
1
29
DTUNER_H
SW_AUDIO_L[PC]
R4257
C4246
SW_C
DVD/AV3_SW
33P
D_SW_1
R4209
SW_CVBS
5.0
D_L1_Vin
2.7K
20
21
22
6dB
0
4.9
26
27
28
29
5.3
3.3
W852
KTK5132E
3.3
3.9K 1/4W
SW_Y
LEVEL SHIFT
Q4210
NC
NC
SW_AUDIO_R[PC]
820
1
C4414
470P CH
3
1SS133
4
STANDBY LED
AT+5V
Vcc
IC4201
0.1 B
C4413
W870
D4209
P.ON LED
5
+
47P CH
1/4W
0.01 B
9.0
0
330
3.9K 1/4W
R4216
AV1_IN
R4402 4.9
6
6dB
3.3
47uH 0305
R4212
SW_A_L
5.0
NC
0.01 B
SW_A_R
3.3
47uH 0305
L4206
C4243
390
470P CH
STANDBY_LED
REMOCON_IN
CP4202_1
A2001WV2-6P
4.5
5.4
B
1
C4223
2
30
7
5.4
7.5
AV1_A_IN_L
B
1
C4222
SCL
L4207
4.5
BIAS
5.0
100
390
C4206
AV1_IN
6dB
7.5
3
AV1_A_IN_L
9
10K
1
B
C4224
100
R4213
47P CH
S1_Y_IN
SDA
R4220
FROM/TO SCALER
CP4203 (CP803)
00_6232_029_006_800+
8
R4219
R4214
C4456
UDZS12B
D4210
R4210
470P CH
1
B
C4221
1 B
10K
C4207
AV1_A_IN_R
D4203
C4251
R4211
AV1_A_IN_R
S1_C_IN
5.7
31
UDZS12B
1 B
C4218
4.5
5.4
33
220 1/4W
D4202
UDZS12B
5.7 C4203
0
C4208
47P CH
C4225
R4401
7.5
0
NC
S1_C_IN
S1_Y_IN
14
B
C4217
CD4202
CU267901
13
12
11
AV2_IN
5.4
35
1
470P CH
UDZS12B
4.7
10
C4227
47P CH
GND
7.5
YUV1_A_IN_L
B
470P CH
AV2_IN
B
1B
5
1 B
S2_C_IN
0
9
YUV1_A_IN_L
1
SCL
4.7
SIDE_Y_IN
UDZS12B
C4239
3.5
8
C4205
7.5
YUV1_A_IN_R
D4211
B C4215
1
C4220
CD3831
CU012202
B
CH
C4250
D4208
3.5
SDA
6
1
1
5.4
SIDE_C_IN
5
47P CH
C4233
47P
S2_Y_IN
0
S_SW_2
4
C4229_1
YUV1_A_IN_R
47P CH
C4228
C4216 470P CH
4.7
0
S_SW_1
C4238
470P CH
32
470P B
C4214
SIDE/DVD_C
4.5
B
SCL
SDA
SW_AUDIO_R[JACK]
SW_AUDIO_L[JACK]
STEREO_RESET
SW_AUDIO_L[PC]
SW_AUDIO_R[PC]
47P CH
C4416
34
SIDE_A_IN_L
1B
YUV2_A_IN_R
4.6 C4202
36
4.7
TUNER_V
C4226
1
17
SIDE_A_IN_R
B
4.7
15
1
Vref
4.5
2
SIDE_A_IN_R
YUV2_A_IN_L
4.5 C4201
18
4.7
SIDE_V_IN
C4230
47P CH
C4213 25V 10 KA
C4231
470P B
SIDE/DVD_Y
H-1
FROM/TO STEREO
100
UDZS12B
16
D4212
C4211
SIDE_V_IN
S_SW_1
1
SW_CVBS
C4242
25V 100 YK
C4210
3
SDA
TO AV JACK2
25V 10 KA
CD3901
CUU33002
1
SCL
B
S2_C_IN
SIDE_A_IN_L
CD3900
CUU21001
2
TUNER_VIDEO
C4232
CD2203
CU23A002
3
SIDE_A_IN_R
C4267
SIDE_S_SW
4
4
SIDE_A_IN_L
6
REMOCON_IN
STANDBY_LED
5
GND
SIDE_A_IN_R
TUNER_VIDEO
FROM/TO SWITCH/AMP
6
SIDE_V_IN
FROM/TO TUNER
YUV2_A_IN_R
5
7
SIDE_S_C
GND
SIDE_A_IN_L
FROM AV JACK
YUV1_A_IN_L
YUV1_A_IN_R
YUV2_A_IN_L
YUV2_A_IN_R
S_SW_1
S_SW_2
S1_Y_IN
S1_C_IN
S2_Y_IN
S2_C_IN
AV1_IN
AV2_IN
AV1_A_IN_L
AV1_A_IN_R
8
SIDE_S_Y
W865
SIDE/DVD_C
6
SIDE_S_L
W867
SIDE/DVD_Y
PCBD20
CMF091
NOTE: THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME
OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE
CAUTION: DIGITAL TRANSISTOR
CAUTION: DIGITAL TRANSISTOR
NOTE:THE DC VOLTAGE AT EACH PART WAS MEASURED
WITH THE DIGITAL TESTER WHEN THE COLOR BROADCAST
WAS RECEIVED IN GOOD CONDITION AND PICTURE IS NORMAL.
1
GND
A
B
C
D
E
F
G
H
H-2
A
B
C
D
E
F
G
H
SWITCH/AMP SCHEMATIC DIAGRAM
(AV PCB)
8
8
FROM/TO AV JACK
SW_YUV1/2
YUV1/YUV2_Y
YUV1/YUV2_PB
YUV1/YUV2_PR
7
EXT_MUTE
FROM/TO AV SWITCH2
7
SIDE_S_SW
REMOCON_IN
STANDBY_LED
AT+5V
AT+3.3V
SW
Q4402
KRA103SRTK
4.9
EXT_MUTE
CP4204
(CP802)
00_6232_030_006_800+
STANDBY_LED
4.7K
R4420
4.9
4.7K
TO AV JACK2
FROM/TO SCALER
R4415
0
STANDBY LED 30
REMOCON_IN
REMOCON IN
AFT
W876
NC
6
AUDIO_MUTE
4.9
FROM TUNER
0
SW
Q4403
KRC102SRTK
AFT
0
YUV1/YUV2_PB
YUV1/YUV2_Y
5
AUDIO_MUTE
4
22
21
18
17
NC
GND
D_IN_1
15
NC
NC
D_LINE3_2
13
NC
SC2 CVBS_OUT-H 12
POWER_FAIL 11
RLY_ON/LCD-H
SIDE_S_SW
NC
SW_YUV1/2
NC
PSU_5VD/DSR/LIGHT_CTL
23
SCART1_B
GND
GND
AFT_2
NC
RLY_ON/LCD-H
POWER_ON-H
AT+5V
AT+3.3V
P.CON+5V
P.CON+9V
24
GND
SCART1_R
VS_ON/LCDON
PSU_ACD/P.FAIL
EXT_MUTE
6
25
20
NC
PSU_5VD/DSR/LIGHT_CTL
VS_ON/LCDON
26
19
POWER_ON-H
FROM/TO POWER
27
HP_MUTE
AUDIO_MUTE
GND
PSU_ACD/P.FAIL
POWER_ON-H
28
AGC
SCART1_G
YUV1/YUV2_PR
TO SOUND AMP/HEADPHONE AMP
29
AFT
16
14
5
POWER_ON-H 10
AFT_1
9
VS_ON/LCDON
8
DVB_FAN_ON-H
PDP_RLY/LCD-H
7
S_DET
D_LINE3_1
5
SW_YUV1/2
3
HP_IN
5VD/LIGHT_CTL
1
6
4
2
4
GND
CD4204
2H0U0802
3
3
2
2
PCBD20
CMF091
NOTE: THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME
OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE
1
H-3
A
B
CAUTION: DIGITAL TRANSISTOR
NOTE:THE DC VOLTAGE AT EACH PART WAS MEASURED
WITH THE DIGITAL TESTER WHEN THE COLOR BROADCAST
WAS RECEIVED IN GOOD CONDITION AND PICTURE IS NORMAL.
C
D
CAUTION: DIGITAL TRANSISTOR
1
E
F
G
H
H-4
A
B
C
D
E
F
G
H
AV JACK SCHEMATIC DIAGRAM
(AV PCB)
8
8
FROM POWER
GND
GND
L4403
P.CON+5V
P.CON+5V
7
16V
7
100 YK
C4464
10uH 0305
TO AV SWITCH2
E
GREEN
4
E
3
H1 H2
150
9
7
E
6
RED
RED
150
H2
BLUE
BLUE
6
H1 H2
8
150
R4268
150
R4272
100P CH
150
C4290
150
R4260
100P CH
R4259
150
C4284
GREEN
5
R4297 R4294
L4215
L
YUV1_A_IN_L
E
1
2
22uH
E
RED
4
6
7
L4217
WHITE
RED
4
8
0.001 B
0.001 B
C4289
C4287
5
22uH
R
YUV2_A_IN_R
YUV2_A_IN_L
H1 H2
L4216
NC H2 NC H1
L
YUV1_A_IN_L
YUV1_A_IN_R
WHITE
3
0.001 B
C4285
C4282
22uH
YUV2_A_IN_L
SW_YUV1/2
AUDIO_IN 4/5
J4204
AV4-57A03-01H
22uH
L4213
R
YUV1_A_IN_R
0.001 B
C4452
25V 10 KA
1M
KA
1M
1M
C4451
25V 10 KA
C4450
1M
C4453
R4295 R4296
C4278
9
100P CH
R4255
10
100P CH
11
150
C4276
12
150
R4242
13
100P CH
R4262
IN3A
IN3B
14
150
C4258
NC
GND3
15
C4454
OUT3
IN2A
16
100P CH
R4240
OUT2
CTL
8
GND2
7
V+
6
OUT1
5
IN2B
4
NC
SW_YUV1/2
5
3
GND1
YUV1/YUV2_PR
B4211
BLM18BB600SN1
NC
IN1B
YUV1/YUV2_Y
YUV1/YUV2_PB
1
BLM18BB600SN1
V
AV5_V
R4269
1M
NC
2
IN1A
COMPONENT SW IC
IC4204
NJM2584AM(TE1)
FROM/TO SWITCH/AMP
1M
25V 10 KA
B4219
V
AV4_V
150
R4298
R4299
25V 10
C4448
25V 10 KA
4
B4205
BLM18BB600SN1
C4449
1
2
BLM18BB600SN1
U
R4271
AV5_U
5
B4220
U
AV4_U
R4270
BLM18BB600SN1
R4267
B4204
Y
150
BLM18BB600SN1
AV5_Y
25V 10 KA
6
B4218
Y
AV4_Y
H1
CS_IN 4/5
J4211
AV6-53-13H
YUV1_A_IN_L
YUV1_A_IN_R
YUV2_A_IN_L
YUV2_A_IN_R
S_SW_1
S_SW_2
S1_Y_IN
S1_C_IN
S2_Y_IN
S2_C_IN
AV1_IN
AV2_IN
AV1_A_IN_L
AV1_A_IN_R
YUV2_A_IN_R
S_SW_1
R4261
S_SW_1
1K
R4250
R4252
TO STEREO
75
1
6
11 5
12
E
13
E
YELLOW
WHITE
WHITE
RED
RED
2
AV2_A_IN_L
L
BLM18BB600SN1L4219
AV2_A_IN_R
R
22uH
L4218
22uH
470P CH
C4272
AV2_A_IN_R
YELLOW
B4217
V
75
C4283
AV2_A_IN_L
BLM18BB600SN1
AV2_IN
0.001 B
R4249
AV2_IN
0.001 B
C4275
2
B4216
Y
R4254
NC H1
S2_Y_IN
B4215
BLM18BB600SN1
C
100P CH
S2_Y_IN
75
C4296
S2_C_IN
100P CH
C4297
S2_C_IN
MTZJ8.2B-EIC
E
22uH
16
L4214
3
D4207
19
1K
H1 H2
22uH
H1 H2
8
L4212
R4251
S_SW_2
4 3
BLM18BB600SN1
NC H1
C4271
S_SW_2
B4214
2
R
BLM18BB600SN1
D4206
MTZJ8.2B-EIC
10 9
L
AV1_A_IN_R
470P CH
AV1_A_IN_L
AV1_A_IN_R
75
C4277
AV1_A_IN_L
0.001 B
R4248
V
0.001 B
C4274
AV1_IN
INPUT 1/2
J4205
SAV-12CP-01Z5
21 20 23 22 17 18 14 15
75
3
BLM18BB600SN1
B4222
Y
R4253
AV1_IN
B4221
C
7
75
100P CH
S1_Y_IN
C4455
S1_C_IN
S1_Y_IN
100P CH
C4288
S1_C_IN
PCBD20
CMF091
H-5
NOTE:THE DC VOLTAGE AT EACH PART WAS MEASURED
WITH THE DIGITAL TESTER WHEN THE COLOR BROADCAST
WAS RECEIVED IN GOOD CONDITION AND PICTURE IS NORMAL.
NOTE: THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME
OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE
1
A
B
C
D
E
1
F
G
H
H-6
A
B
C
D
F
G
H
STEREO SCHEMATIC DIAGRAM
FROM POWER
8
E
W839
AT+5V
(AV PCB)
8
10K
R915
10K
R914
P.CON+5V
4.9
0.6
10V 220 YK
0.6
L901
0
BUFFER
Q902
KTC3875S_Y_RTK
BUFFER
Q901
KTC3875S_Y_RTK
5.0
1K
7
R913
C906
GND
0
7
P.CON+8V
10uH 0305
100
R906
R905
100
FROM/TO HDMI MICON2
22P CH
22P CH
C949
220P CH
C948
C943
470P CH
C945
C941
C933
6.3V 1000 YK
C904
50V 22 YK
MTZJ5.6B-EIC
W894
R902
4.9
80
0
0
NC
0
NC
4.4
NC
STEREO_RESET
73
72
10P CH
71
C957
CH
56P
FROM TUNER
4
C954
66
56P CH
63
64
65
NC
4.9
NC
AVSS
AVSUP
AVSS
MONO_IN
50V 1 KA
SIF
4.9
VREFTOP
5
67
SIF
NC
SP_AUDIO_OUT_R
C955
C953
2.4 56P CH
62
0
50V 1 KA
70
ANA_IN-
65 AVSUP
C960
68
1.9
59
60
61
0 NC4.8 NC 0
6
5P CH
69
SW_A_IN_L
(AV1/YUV/SIDE)
SW_A_IN_R
0 NC 0 NC
C946
50V 10 YK
C944
0.1 B
C952
0.33 B
0.33 B
C940
C942
C936
C934
ANA_IN2+
55
56
57
58
0 3.8 3.8 2.6
0.33 B
C963
ASG1
SW2_A_IN_L
(PC/HDMI/DVI)
SW2_A_IN_R
52
53
54
0 3.8 3.8
0.33 B
(AV2)
AV2_A_IN_R
ASG2
AV2_A_IN_L
51
0.33 B
C962
50
0.33 B
ASG4
SW1_A_IN_L
(DVD)
SW_A_IN_R
48
49
3.8 NC 0
NC
50V 3.3 KA
C918 0.0015 B
50V10 YK
0 NC 3.8
0.1 B
C920
44
45
0 3.7
C927
470P CH
43
0
AGNDC
42
C926
41
0 NC 0 NC
C917
3
47
AHVSUP
7.1
50V10 YK
FROM/TO AV SWITCH2
46
CAPL_A
8.0
40
C914
NC
7.1
39
50V 10 YK
40 CAPL_M
AHVSS
100
C915
VariOut_L
S801X
0
X901
NC 100CT01803
2.4 18.432MHz C956
2.6
3.8
1
C961
1.9
XTAL_IN
AHVSS
R916
AUDIO_JACK_OUT_L
16V 22 KANP
XTAL_OUT
TESTEN
NC
100
VariOut_R
38
4
C919
VREF1
2
GND
SP_AUDIO_OUT_L
0
37
16V 22 KANP
TP
3.8
R904
AUDIO_JACK_OUT_R
3
TO SOUND AMP/HEADPHONE AMP
B
0
NC
C959
34
SC2_OUT_L
HDMI_I2SSDO
HDMI_I2SWS
0.0022
33
SC2_OUT_R
AUDIO_CL_OUT
STEREO IC
IC904
MSP4440G-QA-C13-100
HDMI_I2SSDO
HDMI_I2SWS
0.0022 B
0
NC
3.8
NC
DACM_SUB
NC
C916
79 ADR_SEL
D_CTR_I/O_1
C958
32
NC
NC
0
26 VREF2
BLM18BD102SN1
CD901
CU247001
W856
78
0
NC
77
31
NC
0
NC
30
0
NC
0
NC
35
TO AV JACK2
80 STANDBYQ
NC
36
5
0
NC
L904
1
NC
2
D_CTR_I/O_2
25 NC
W920
B906
CP901
A2001WV2-4P
HDMI_I2SSCK/MCKL4
W857
2.5
3
HDMI_I2SSCK
GND
79
I2S_WS
1.7
4
I2C_DA
5
0.1
13
BLM18BD102SN1
0 NC
I2C_CL
5.0
I2S_CL
6
I2S_DA_OUT
7
I2S_DA_IN1
ADR_WS
8
ADR_DA
9
DVSUP
10
ADR_CL
DVSUP
0 4.9 4.9 4.9
14
13
12
11
DVSS
0
15
DVSUP
0
16
DVSS
I2S_DA_IN2
NC
I2S_CL3
17
5.0
76
NC
18
0 NC 0 NC 0 NC0.2 NC5.0
NC
75
SPOUT_L
19
B904
33
74
27
SPOUT_R
28
0.1
29
12
20
RESETQ
I2S_DA_IN3
26
0
21
DVSS
0 NC 0 NC 0 NC0.2 NC
I2S_WS3
22
NC
25
23
NC
24
0
NC
W892
W893
6
0 NC 0 NC 0 NC 4.9
33
R903
10uH 0305
D901
C922
0.1 B
0.0015 B
L903
10uH 0305
470P CH
C950
0.0015
B
C951
50V 10 YK
3
SCL
SDA
SW_AUDIO_L[PC]
SW_AUDIO_R[PC]
SW_AUDIO_L[JACK]
SW_AUDIO_R[JACK]
2
2
FROM AV JACK
AV2_A_IN_L
PCBD20
CMF091
AV2_A_IN_R
GND
1
H-7
NOTE:THE DC VOLTAGE AT EACH PART WAS MEASURED
WITH THE DIGITAL TESTER WHEN THE COLOR BROADCAST
WAS RECEIVED IN GOOD CONDITION AND PICTURE IS NORMAL.
NOTE: THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME
OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE
A
B
C
D
E
1
F
G
H
H-8
A
B
C
D
E
F
G
H
SOUND AMP/HEADPHONE AMP SCHEMATIC DIAGRAM
(AV PCB)
8
SOUND AMP IC
IC301
TA2024-ASE
24.0
0
R311
10K
C323
AT+5V
47K
470K
0.1 B
SW
0
Q300
KTC3875S_Y_RTK
R324
W884
R338
0
3.0
0.1 B
BIASCAP
NC
0
B
F
0.1
C354
C352
1/2W 0.47
R320
10
B
C348
B 0.47
C349
0.47
B
0.1
C355
R321
B
10 1/2W
PGND2
SLEEP
FAULT
0
C363
C359
470P CH
30
NC
0
AGND3
6
SPEAKER
1
NC
2
2
SP OUT R+
1
3
SP301
EAS12D175B
4 OHM 10W
SPEAKER
SP303
EAS5PH134C
4 OHM 10W
TR302
W5T29X7.5X19
5
0
HS78
HS300
763WAAA066
NC
W907
GND
SOUND_GND
SOUND+B
DGND
3
10uH7313N
0
16
5
INV2
C332 2.5
4 OHM 10W
CD301
CU13A301
470P CH
22K
1 KANP
17
50V
18
680
FROM POWER
23
0
2
(R)
470P CH
2.5
1
SP302
EAS12D175B
7
C358
R315
C342_2
NC
25V 1000 MHE
SP OUT L-
NC
22
22K
C319
R302
15
2
0
NC
1
SP OUT R-
C362
OAOUT2
OUTP2
L303
2
CP301
A2502WV2-3P
470P CH
13
NC
14
NC
R319 2.5
24
6.0
0
C353
VDD2
B
10uH7313N
0.47 F
MUTE
0.1
25
11.0
SP OUT L+
SPEAKER
6
C350
VDD2
0
D304
INV1
22K
21
50V 1 KANP
W886
12
680
C341
D305
11
SP_AUDIO_OUT_L
26
11.0
2.5
5
(L)
CD303
CU12A601
20
R314
CP303
A2502WV2-2P
L302
27
10
OUTM2
4 OHM 10W
TR301
W5T29X7.5X19
10uH7313N
6.0
OAOUT1
L301
28
OUTM1
19
0.1 B
C331
9
V5A
22K
C320
B
6.0
5.5
R318 2.5
R304
0.1
29
11.0
10uH7313N
0.47
VDD1
C339
B
AGND2
11.0
4
L300
C351
VDD1
SP304
EAS5PH134C
25V 1000
MHE
0.47
7
OVERLOADB
OUTP1
31
6
REF
+-1%
FROM STEREO
3
NC
D302
NC
32
5
AGND1
C340_2
6.0
0
SP_AUDIO_OUT_R
7
SPEAKER
0
0
0
NC
6
0.1 B
D303
VDDA
8
8.2K
C338
33
4
0.1 B
C326
VD5
390P CH
S801Y
NC
11.0
0
R317
34
NC
5.5
C301
35
2
3
C328
0.1 B
DCAP1
PGND1
14.0
7
50V 1 KANP
0
23.0
DCAP2
C337
CPUMP
EC31QS04 EC31QS04
+5VGEN
36
1
5.5
EC31QS04 EC31QS04
0.1 B
C324
8
NC
C304
D306
FROM SWITCH/AMP
RB520S-30-TE61
0.1 B
4
4
POWER_ON-H
C364
16V 220 YK
AUDIO_MUTE
3
1K
4.8
SW
Q301
KTC3875S_Y_RTK
0
3
0
SW
Q302
KTC3875S_Y_RTK
4.8
R325
4.7K
R323
4.7K
R322
C365
16V 220 YK
0
0
2
2
W910
1
H-9
PCBD20
CMF091
W911
NOTE:THE DC VOLTAGE AT EACH PART WAS MEASURED
WITH THE DIGITAL TESTER WHEN THE COLOR BROADCAST
WAS RECEIVED IN GOOD CONDITION AND PICTURE IS NORMAL.
NOTE: THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME
OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE
A
B
C
D
PIECES REPAREES PAR UN
ETANT
ATTENTION:LES
DANGEREUSES AN POINT DE VUE SECURITE
N’UTILISER QUE CELLS DECRITES
DANS LA NOMENCLATURE DES PIECES
E
THESE PARTS MARKED BY
CAUTION:SINCE
CRITICAL FOR SAFETY,USE ONES
1
ARE
DESCRIBED IN PARTS LIST ONLY
F
G
H
H-10
A
B
C
D
E
F
G
H
POWER SCHEMATIC DIAGRAM
8
8
(AV PCB)
C3835
150P CH
C3831
14
AT+5V
0
17.0
6
9.5
7
30.9
30.6
C3832
C3833
0.22 MMTS
C3837
C3834
C3830
50V 4.7 YK
TO SWITCH/AMP
0.22 MMTS
50V 4.7 YK
5.1
CREG COUT
22uH TSL0808
6
P.CON+9V
P.CON+5V
AT+5V
AT+3.3V
GND
P.CON+8V
3.3V_REGULATOR IC
IC3804
PQ070XF01SZH
1H3-E
REG +3.8V IC
BA7810T-V5
IC3808
P.CON+5V
AT+5V
GND
5
TO AV JACK
3
W842
R3835
C3827
4
CTL
Vcc
GND
Vout
1
2
3
4
3.2
4.6
0
W835
ADJ
D3809
P.CON+5V
5
3.9
GND
1.2
W890
5.3
R3834 R3831
0.3
10V 100 YK
C3820_1
7.5
4
R3857
EC31QS04
330
+-1%
+-1%
GND
2
R3858
OUT
1
TO AV SWITCH2
1.8K
IN
NC
AT+5V
AT+3.3V
P.CON+9V
P.CON+5V
GND
1K
NC
NC
R3856
NC
12
YK
11
C3848
GND
5
10V 100 YK
10
CP2
4
1 F
GND
CP2
3
R3855
9
GND
2
15K
12VSC
CP1
1
C3829
22K
12VSC
8
8
CP3
CP1
22K
7
L3803
C3806
GND
9
CP3
TO STEREO
100P CH
GND
6
10
NC
D3804
C3802
5
C3801
GND
11
NC
16V 1000 FM
4
22uH TSL0808
7
P.CON+32V
33.7
12
0.22 MMTS
6.3V 1000
CD3803
CU6C2901
5VSC
17.8
NC
0.22 MMTS
L3802
16V 1000 FM
5
5VSC
3
0
GND
B
C3828
CP3803 (CP510)
A2501WV2-12P
1
5VSC
13
0
P.CON+5V
0.01
FROM/TO POWER MODULE
0
CVCC COSC
9.4
6
2
4.2
TO TUNER
0.22 MMTS
100
C3847
GND
C3803
2
10uH TSL0808
9VSC
L3810
1
22uH TSL0808
5.0
P.CON32V REG IC
IC3805
LA7995M-TLM
CP3802 (CP509)
A2501WV2-2P
16V 1000 FM
L3801
1H3-E
CD3802
CU622201
D3805
7
0.22 MMTS
C3836
4
FROM SWITCH/AMP
C3804
FROM/TO PDP POWER MODULE
4
GND
5
VS ON/LCDON
6
5VD/LIGHT_CTL
7
NC
C3805
AT+5V
C3839
0.0056 B
S
1K
2 24 0 NC
R3830
1.2K
0
R3833
6.8uH
1
P.CON+9V
2
P.CON+5V
3
AT+3.3V
4
P.CON+3.8V
5
P.CON+3.8V
6
GND
7
GND
8
10
C3825_2
1.2K
R3832
23.5
24
P.CON+3.8V
SW
Q3806
KTC3875S_Y_RTK
23.5
7
0
23.5
D3803
SBR100-10J-CBC11
1
6
AT+3.3V
10uH7313N
P.CON+12V
GND
SW
Q3807
KTA1505S
-Y-RTK/P
10
5
24
0.047 B
1.5V 1V 1.7
4
0.25
W945
HS6S
HS3801
763WAAA070
GND
3
9
P.CON+5V
10
AT+5V
11
AT+5V
TO SOUND AMP/HEADPHONE AMP
2
AT+5V
GND
500V 560P B
W836
R3828
C3823
35V 1000 FM
B
C3822
3
C3819
RCH8011NP-6R8L
L3805
2
430P CH
1
0.7
0.1
BD9300FV-E2
0
SW
Q3808
2SJ650
P.CON+9V
L3808
10
24
IC3803
22K
C3817
R3820
3.5
R3823
SOUND GND
P.CON+12V
1.2 1.2 1.2 2.5 17.5 0 22.5
14 13 12 11 10 9 8
10K
C3821
SOUND GND
4
0
SW
Q3802
KRC102SRTK0
SW
Q3805
KRC102SRTK
15K +-1%
3
0
0
R3822
30V or 24V
SW
Q3801
KRA103SRTK
R3821
2
2
0
5
C3816
5
33K
4.7K
50V 4.7 YK
5
0.1 B
R3803
4.7K
5
Q3804
KRA103SRTK
TO SCALER
CP3807 (CP3201)
A2001WV2-11P
6.8uH
SW
R3808
CP3801 (CP511)
A2501WV2-4P
30V or 24V
1
6.8K
+-1%
2
33K
R3825
100K
+-1%
D
100K
R3824
3
R3826
R3827
CD3804
CU672301
R3806
G
47K
C3849
R3802
NC
CD3807
CU2B3901
RCH8011NP-6R8Lor
SBC4-6R8-452
L3809
22uH TSL0808
W821
3
47K
L3804
25V 1000 MHE
5VST_BY/AT+5V
PSU_ACD/P.FAIL
PSU_5VD/DSR/LIGHT_CTL
VS_ON/LCDON
RLY_ON/LCD-H
POWER_ON-H
C3826_2
RLY ON/LCD-H
3
220K
R3801
25V 1000 MHE
2
B
6.3V 1000
YK
0.001
R3805
CP3804 (CP506)
A2501WV2-7P
ACD/P.FAIL
1
SOUND+B
SOUND_GND
PCBD20
CMF091
1
H-11
NOTE: THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME
OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE
A
NOTE:THE DC VOLTAGE AT EACH PART WAS MEASURED
WITH THE DIGITAL TESTER WHEN THE COLOR BROADCAST
WAS RECEIVED IN GOOD CONDITION AND PICTURE IS NORMAL.
B
C
PIECES REPAREES PAR UN
ETANT
ATTENTION:LES
DANGEREUSES AN POINT DE VUE SECURITE
N’UTILISER QUE CELLS DECRITES
DANS LA NOMENCLATURE DES PIECES
D
THESE PARTS MARKED BY
CAUTION:SINCE
CRITICAL FOR SAFETY,USE ONES
ARE
CAUTION: DIGITAL TRANSISTOR
CAUTION: DIGITAL TRANSISTOR
1
DESCRIBED IN PARTS LIST ONLY
E
F
G
H
H-12
A
B
C
D
E
F
G
H
AV JACK2 SCHEMATIC DIAGRAM
8
8
(AV PCB)
7
7
E
4
V
H1
B4206
BLM18BB600SN1
L
R
6
1
0
75
5
R4245
0
R4263
16V 470 YK
E
33
C4279
BUFFER
Q4201
KTA1504S_Y_RTK
H2
SW_CVBS
4.5
3
R4241
CVBS/AUDIO OUT
J4201_1
AV3-13P2-11S1
H1
2
0
C4273
0.2
R4247
1K
MUTE SW
Q4211
KTA1504S_Y_RTK
0
16V 100 YK
6
47K
R4246
R4244
FROM/TO AV SWITCH2
MUTE SW
Q4200
KTA1504S_Y_RTK
1K
0.8
8.8
0
MTZJ6.8B-EIC
220
1/2W
1K
10K
D4205
R4239
R4243
L4211
100uH 0305
FROM STEREO
R4235
R4237
R4236
L4220
R4238
270
100
FROM/TO POWER
22uH
330
0
0.3
0
0
MUTE
Q4207
0 KTC3875S_Y_RTK
C4301
330
R4229
L4221
MUTE
Q4209
KTC3875S_Y_RTK
C4300
0.3
R4232
5
22uH
270
5
0.001 B
100
AUDIO_JACK_OUT_R
0.001 B
AUDIO_JACK_OUT_L
P.CON+9V
GND
FROM SWITCH/AMP
4
4
EXT_MUTE
3
3
2
2
PCBD20
CMF091
NOTE: THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME
OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE
1
H-13
A
B
C
NOTE:THE DC VOLTAGE AT EACH PART WAS MEASURED
WITH THE DIGITAL TESTER WHEN THE COLOR BROADCAST
WAS RECEIVED IN GOOD CONDITION AND PICTURE IS NORMAL.
D
E
1
F
G
H
H-14
A
B
C
D
18
19
NC 1
NC
NC 2
NC
C5802
0.1 B
0.001 B
P.CON+5V
BLM18PG181SN1D
22uH 0305
NC
NC
NC
R5805
R5800
100K
AT+5V
150K
GND
FROM SWITCH/AMP
AFT
C5806
NC
NC
9
NC
7
FROM/TO AV SWITCH2
0.001 B
R5801
NC 8
C5807
47K
IF OUT
P.CON+32V
0.1 B
NC 5
7
8
FROM/TO POWER
NC
BT
H
L5800
B5802
NC 4
7
G
C5803
6.3V 1000 YK
C5804
3
+B
C5801
F
TUNER SCHEMATIC DIAGRAM
(AV PCB)
TU5800
115-V-LA35ARH J
8
E
68P CH
SCL
R5802
SDA
SCL 10
100
TUNER_VIDEO
IR-THROUGH
R5803
SDA 11
100
AFT 12
C5809
AUDIO OUT13
6
W844
SIF OUT 14
0.1
BLM18PG181SN1D
NC 16
6
SIF
C5810
B5801
+32V 15
B
C5811
NC
0.1 B
C5812
VIDO OUT 17
35V100 YK
21
20
TO STEREO
68P CH
NC
C5815
L5801
39P CH
22uH
11
5
5
L2275
3
2
10K
+
-
4
0
R2278
C2278
220P B
1
0.1
8
5.2
7
C2275
0.01 B
220K
16V 47 YK
C2276
12K
150
0.1 B
R2276
R2279
C2277
220K
0
0.2
5
-VS
4
0
6
3
+
R2277
0.2
0.01 B
C2281
0.01 B
R2280
SW
Q2275
0
KTC3875S_Y_RTK
1.2K
C2280
4.5
1 KA
4.9
220
0
0.3
2.7K
R2284
4.5
C2279
22
R2288
4.6
SW
Q2276
KTA1544T-RTK/P
10K
R2282
56
R2289
2
C2283
R
BLM18BB600SN1
100P CH
L
OUT PUT
B2271
330
R2281
1SS355
4.8
+VS
50V
R2286
0.5
IR PASS THROUGH
J2275
MSJ-035-12A_PC
C2282
4.9
D2275
Q2277
KTA1504S_Y_RTK
R2283
4
16V 47 YK
SW
2.7K
R2285
1
R2287
OPE AMP
NJM4580V(TE1)
IC2275
12K
R2275
47uH
PCBD20
CMF091
1
3
3
ACCESSORY
CD801
(REMOCON PCB)
CH011208
CD802
CH011208
CD3801
CU643701
W919
R2253
3 B+
47 1/4W
680K
PANEL
FILTER
V801
PDP50X3####
V802
FG510NAA-05
BT001
MNAAA(R03)
TM101
076D0KK030
BT002
MNAAA(R03)
2
B
W848
CH010903
25V 10 KA
C2255_1
220K
1SS133
12K
R2254
D2252
390K
W917
R2255
STANDBY/POWER
D2251
LTL-1BEFJ-002A
R2257
POWER ON LED
1
1K
6
C2252
STANDBY LED
6.3V 100 KA
5
R
AT+5V
G
GND
4
PIN PHOTO DIODE
Q2251
HPI6FGR4F2 4.9
C2256
3.5
W889
OS2251
ROM-V338TAO
REMOCON IN
3
0
CD804
R2259
CP2251
A2001WR2-6P(CP2201)
IR-THROUGH
1
2
2 GND
R2252
R2256
BUFFER
5.2
Q2252
KTC3875S_Y_RTK
2.8
1 Vout
FROM/TO AV SWITCH/SIDE JACK
2
270
CD3820
0T024504
PCBDA0
CEF211
1
1
NOTE: THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME
OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE
H-15
A
B
PIECES REPAREES PAR UN
ETANT
ATTENTION:LES
DANGEREUSES AN POINT DE VUE SECURITE
NOTE:THE DC VOLTAGE AT EACH PART WAS MEASURED
WITH THE DIGITAL TESTER WHEN THE COLOR BROADCAST
WAS RECEIVED IN GOOD CONDITION AND PICTURE IS NORMAL.
C
D
THESE PARTS MARKED BY
CAUTION:SINCE
CRITICAL FOR SAFETY,USE ONES
N’UTILISER QUE CELLS DECRITES
DANS LA NOMENCLATURE DES PIECES
E
F
ARE
DESCRIBED IN PARTS LIST ONLY
G
H
H-16
A
B
C
D
E
F
G
H
MICON SCHEMATIC DIAGRAM
8
P.CON+5V
EEPROM_SCL
D
S
PSU_5VD/DSR
G
R194
4.7K
45
42
41
40
39
38
0
JG102
0
JG105
0
R134
R119
1K
0
JG127
3.2
3.2
0
1K
1K
R122
0
R181
0
4.7K
COMPONENT/HDMI
JG130
14
15
16
17
18
19
20
21
22
23
24
25
0 3.09 3.2 3.2 3.3 3.16 3.2
0
0 3.2
0
0 3.2
34
R146 100
0
3
4SI_SDA_OUT
2
GND
1
R147
3.2
3.2
R148
3.2
100
3.2
DVD_RX
100
CP101
A2001WV2-5P
1
GND
DVD_TX
EEPROM_SCL
EEPROM_SDA
0
IIC_OFF
EEPROM_SCL
2
EEPROM_SDA
3
IIC_OFF
4
GND
5
RESET IC
IC102 PST3229NR
4
NC
DVD_TX
RST1
NC
OUT
IN
GND
1
2
3
3.4
3.4
CLK1
DVD_RX
CNVSS
0
W895
C
D
E
3
NC
4
VCC
5
CLK
6
RX
7
CNVSS
8
RESET
9
GND
10
3
SCL
TEST
VCC
2
1
EEP ROM IC 256K
IC103
AT24C256N-10SU-2.7
SDA
3.3
3
2
1
SDA2
F
0
0
EEP ROM IC 256K
VCC
VSS
R174
0
B
0
TEST
A2
4
100
100
CAUTION: DIGITAL TRANSISTOR
3.3
3.3
SCL2
8
SCL
W896
7
A1
R173
6
SDA
CAUTION: DIGITAL TRANSISTOR
ARE
2
2
R188
5
THESE PARTS MARKED BY
CAUTION:SINCE
CRITICAL FOR SAFETY,USE ONES
3
A0
8
A1
7
GND
50V2.2 V-S
6
EEPROM_SDA
DV1000_RESET
SCL1
SDA1
A
5
4
EEPROM_SCL
N’UTILISER QUE CELLS DECRITES
DANS LA NOMENCLATURE DES PIECES
DESCRIBED IN PARTS LIST ONLY
FROM/TO VIDEO ENHANCER
JG134
PIECES REPAREES PAR UN
ETANT
ATTENTION:LES
DANGEREUSES AN POINT DE VUE SECURITE
NOTE:THE DC VOLTAGE AT EACH PART WAS MEASURED
WITH THE DIGITAL TESTER WHEN THE COLOR BROADCAST
WAS RECEIVED IN GOOD CONDITION AND PICTURE IS NORMAL.
NC
W820
AT+5V
TX
BUSY
10K
C128
C126
100
R115
SDA1
C125
100
R114
SCL1
0
NC
5
NC
10K
D105
RB520S-30-TE61
1K
R163
DDVS
R135
0.01 B
R208
4.7K
4.7K
R110
R164
100
C_SYNC_POP
POWER_ON-H
4.7K
R116
4.7K
DDHS
27K
R109
RB520S-30-TE61
POWER_FAIL
REMOCON_IN
D109
18P CH
0.1 B
R117
0
C136
R107
R128
A0
SD_SW1
YUV_SW
ROM WRITER
MICON_DATA
CP102 A2001WV2-10P
1
GND
4.7K
JG112
NOTE: THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME
OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE
C_SYNC
C_SYNC_POP
4
0
GND
FROM/TO AV SWITCH
H-17
4
4SI_SDA_IN
5
CLK1
4.7K
C113
0.1
C114
C118
18P CH
C111
B
0.1
C109
4SI_SDA_OUT
4SI_SCL
R127
100WT01611
16MHz
X101
4.7K
CNVSS
4SI_SDA_IN
4SI_SCL
4SI_SDA_IN
RESET
CHIP_SELECT
6
JG136 RST1
0
4.7K
14
4SI_CHIP_SE
DVB_TX
100
R149
0 3.2 3.3
0
4.7K
13
R145
5
7
4SI_SCL
JG135
DVB_RX
R209
12
0
CP103
A2001WV2-7P
SCALER_RESET
DV1000_RESET
1K
0.1 F
0
11
HDMI_H
0
JG131 R198
W897
AT+3.3V
1K
6.3V 100 V-S
0
5.6K
YUV_SW
1K
JG129
C131
10
R106
R157
R156
4SI_SDA_OUT
SCALER_SW
50V0.47 V-S
9
JG118
R105
4.7K
4.7K
4.7K
4.7K
R155
R154
R123
4.7K
8
4.7K
4SI_CHIP_SE
10K
C_SYNC
R160
R121
R126
0
B
0
7
28
6
27
5
DVD_TX
26
4
R161
C110
HDMI/DVI
1K
4.7K
DVD_RX
6.3V 220 V-S
SD_SW1
R140
(CLK1)
26 NC
P.CON+3.3V
AT+3.3V
P.CON+3.3V
SCALER-H
P.CON+5V
AT+5V
HDMI_H
STANDBY_LED
R120
0
R138
27 SCL1
STEREO_RESET
10K
4.7K
0
4.7K
99 DVD/AV3
100 NC
3
R151
6
JG106
4.7K
PANEL_READY
VREF
2
0
7
4.9
4.7K
R118
(RST1)
31
98 DIGI/ANA_CVBS
3.2 3.4 3.2 3.2 3.2
FROM/TO REGULATOR
R193
R178
0
R129
37
36
35
28 SDA1
33
DVB_TX
32
DVB_RX
30
KEY-B
3
D
G
50
49
48
47
EEPROM_SDA
DVB_SW-H
EEPROM_SCL
HDMI_H
1
SW
Q101
KRC103SRTK
0
DV1000_RESET
AVCC
0
3.3
KEY-B
0
YUV_SW
POD_DET
A_TUNER_AFT
AVSS
DVD_SW-H
AUDIO_MUTE
SW
Q105
KRA103SRTK
5.0
0
5.6K
COMPONENT/HDMI
PDP_RLY/PDPGO
KEY-A
AT+5V
SCALER_SW
VS_ON/CPUGO
KEY-A
DVB_FAN_ON-H
3DY/C_RESET
EXT_MUTE-H
HDMI/DVI
29
LCDON/PDWN
HDMI_H
1
AUDIO_MUTE
VCC2
HP_MUTE
VSS
SCART_AUDIO_SW
SCART1_SW/S_DET!
SCART3_SW
SCART2_SW/S_DET2
DVB_RESET-L
DTV/DVD_SW
EPM
TO INTERFACE_HDMI
2
STEREO_RESET
DVB_MUTE-L
DVB_POWER_CTL-H
A_TUNER_AGC_IN
V_SYNC
COMPOSITE/RGB
DVB_ASPECT_IN
5VD
SD_H
77
79
80
81
82
83
84
AFT_2(HIGH)
1K
SCL1
SDA1
DDHS
DDVS
SW_POP1
DDVS
0
NC
1K
SD_SW1
P50/^WRL/^WR
LIGHT_CTL
R200
DVD/AV3
SW_POP2
SDA2
FROM/TO ADC
50 SC2_CVBS_OUT-H
SCL2
0
R199
DIGI/ANA_CVBS
53
48 STANDBY_LED
JG116
SD_H
0
54
C_SYNC_POP
DVB_RESET-L
DVB_POWER_CTL-H
SCALER_SW
51
55
DVD POWER ON-H
3.2
52
56
SYNC_HD_IN
3.2
57
POWER ON-H
0.1 F
C101
6.3V 220 V-S
C107
0
58
4.7K
4
2.2K
R103
AFT_1[LOW]
AFT_2[HIGH]
DVB_MUTE-L
DVB_RX
DVB_TX
2.2K
R104
0
JG137
59
POWER FAIL
DVS
61
REMOCON IN
KEY-A
62
NC
3.2
65
VCC1
3.2
66
XIN
0.1 B
67
XOUT
C104
68
VSS
1.4
W907
AFT
DVB_AFT
KEY-B
69
RESET
0
PDP_RLY
0
(32KHz_OUT)
0
0
CNVSS
3.2
VS_ON
0 3.4 3.2 3.2 3.2
(32KHz_IN)
0
BYTE
JG104
AFT_1(LOW)
4SI_CLK
AFT_2[HIGH]
LCD_H
4SI_DATA_IN
0
0
MICON IC
IC101
OEC7164A
4SI_DATA_OUT
JG103
78
76
3DY/C_RESET
SW_SCART/COMPONENT_SW
85
4.7K
0
76 SCALER-H
IIC_OFF
86
R102
3.2
0 3.2
47
87
3.2
1K
S_JACK_IN_DET
88
SW_SCART
IIC_OFF
0
49 SC2_AUDIO_OUT-H
HDMI_SW
89
0
R175
0 2.75 2.75
75 HEADPHONE_IN
4SI_CHIP_SE
PSU_5VD/DSR
0
JG120
HDMI_SW
SCALER_RESET
90
VS_ON
PDP_RLY
0
91
SW_SCART
SCART_AUDIO_SW
3.2
4.7K
S_DET
SW_HD/SCART_Y
92
AUDIO_MUTE
SCALER_RESET
S_DET
SCALER_RESET
R158
JG101
0.1 B
93
5
C106
DVD_RESET
94
4SI_SDA_OUT
4SI_CHIP_SE
0
DISC_IN_DET
0
95
SCL1
4SI_SCL
4SI_SDA_IN
3.2
0
60
R192
DVB_FAN_ON-H
0
63
COMPONENT/HDMI
EXT_MUTE-H
AFT_1[LOW]
0
64
DVD_TX
HDMI/DVI
EEPROM_SDA
R195
96
STEREO_RESET
SDA1
0
97
HP_MUTE
3.2
98
POWER_ON-H
0.1 B
100 99
POWER_FAIL
C123
SCALER-H
C_SYNC
6
DVB_FAN_ON-H
DVD/AV3
DIGI/ANA_CVBS
STANDBY_LED
REMOCON_IN
AFT
SCART2_SW
SCART1_SW
SCART1_Y
EXT_MUTE-H
0 2.51
71 70
100
46
0.1 F
0
72
4.7K
44
100
0
73
100
R142
100
SCART1_Y
DVS
0
74
R141
4.7K
R136
43
C117
0
75
R137
JG107 4.7K
100
R133
6.3V 220
V-S
R204
HP_MUTE
SCART1_SW R132
SCART2_SW
C116
R205
SD_H
FROM/TO SCALER
DVD_RX
LEVEL SHIFT
Q106
KTK5132E
S
4.7K
4.7K
R176
R131
7
FROM/TO JACK
100
4.7K
POWER_ON-H
SCART_AUDIO_SW
DVB_RESET-L
DVB_POWER_CTL-H
DVB_MUTE-L
R177
SCL2
JG114
SDA2
10K
IC104 AT24C256N-10SU-2.7
FROM/TO LVDS
LEVEL SHIFT
Q104
KTK5132E
(SCALER PCB)
8
R189
10K
PCBDS0
CEF156
1
0
G
H
H-18
A
B
C
D
E
F
G
H
SCALER SCHEMATIC DIAGRAM
8
8
(SCALER PCB)
FROM/TO SWITCH/AMP
FROM/TO MICON
CP802 (CP4204)
00_6232_030_006_800+
AFT
SCART1_SW
28
SW_YUV1/2
NC
29
30 LIGHT CTL/PSU_5VD
5
W877
W823
CP803 (CP4203)
00_6232_029_006_800+
2
D/A_SW/INV_DET
3
SPIF/DTV_A_R
SPIF_134
5 POP_S_Y/DTV_A_L
6.3V 220
V-S
DVD/AV3
DVB_MUTE-L
W981
W805
SW_R/SW_CR
C812
0.1 B
C816
0.1 B
W980DIGI/ANA_CVBS
W978
C839 0.1 B
C840 0.1 B
C841 0.1 B
C815
VS_ON
W979
W821
4
6
C814
0.1 B
PSU_5VD/DSR
C801
1B
1 DVD/AV3_SW/SPDIF
C823 0.1 B
SW_SCART
C830 0.1 B
D802
UDZS5.6B
DVB_RX
C826
8
0.1 B
W982
GND
DVB_TX
10
11
12
SW_AUDIO_R[PC]
GND
13 SW_AUDIO_L(PC)
SW_AUDIO_L[PC]
C832 0.1 B
C818
0.1 B
W983 DVB_RESET-L
GND
SW_AUDIO_R(PC)
D803
UDZS5.6B
C834 0.1 B
SW_B/SW_CB W807
W990 SCALER_SW
C845
C846
C847
14
15
STEREO_RESET
16
SCART3_SW
17
3
19
SDA1
SCL1
20
GND
21
DVD_Y_OUT
22
GND
23
DVD_C_OUT
24
GND
25
27
C876 0.1 B
W984
SWITCH_VIDEO_C
C820
DVB_POWER_CTL-H
D805
UDZS5.6B
0.1 B
W985
SD_H
C827
W931
W802
W930 W809
15
SW_CVBS
0.1 B
R807
10K
SW_VIDEO_Y
16
17
W929 W801
SW_VIDEO_C
C835
29
0.1 B
SCL1
SWITCH_VIDEO_Y
GND
0.1 B
0.1 B
0.1 B
C859 0.1 B
SW_VIDEO_Y
SDA1
GND
28
0.1 B
C819
SCART_AUDIO_SW
SWITCH_CVBS
26
C817
STEREO_RESET
SCART_AUDIO_SW
18
0.1 B
0.1 B
0.1 B
SW_VIDEO_C
9 POP_CVBS/DVD_A_L
4
C842
C843
C844
GND
7 POP_S_C/DAD_A_R
B
C850
0.1
H-19
DPG3
DPG2
DPG1
DPG0
DDCK
0.1 B
C878
0 NC
0 NC
0 NC
0 NC
0 NC
1.8
0
0 NC
0 NC
0 NC
3.3
0
3.3
C873
0.1 B
C877
0.1 B
0.1 B
C871
MPWEL
108 DGND
B
R825
1M
NR801
4D03WGJ0000T5E
NC NC NC NC
B
C898
0
1.8
0 NC C889
0 NC
0 NC 0.1 B
3.3
3.3
3.3
3.3
3.3
3.3
0
1.8
3.3
3.3
3.3
3.3
3.3
3.3
3.3
3.3
3.3
3.3
0
1.8
3.3
3.3
3.3
3.3
3.3
0
3.3
3.3
3.3
3.3
3.3
0
1.5 R835 10K
R834
0
3.3
10K
NR802
4D03WGJ0470T5E
NR803
4D03WGJ0470T5E
C895
0.1 B
C896
0.1 B
C821
0.1
NR804
4D03WGJ0470T5EDB9
DB8
DB7
DB6
NR805
4D03WGJ0470T5EDB5
DB4
DB3
DB2
DG9
DG8
DG7
DG6
NR807
4D03WGJ0470T5E
DG5
DG4
DG3
DG2
B
PDP_RLY
VS_ON
PSU_5VD/DSR
HDMI/DVI
SCART_AUDIO_SW
DVS
DVB_FAN_ON-H
SCALER_SW
AFT_1[LOW]
AFT_2[HIGH]
5
DVB_MUTE-L
DVB_RX
DVB_TX
DVB_RESET-L
DVB_POWER_CTL-H
SD_H
DR2
DR3
DR4
DR5
DR6
DR7
DR8
DR9
DG2
DG3
DG4
DG5
DG6
DG7
DG8
DG9
FROM INTERFACE_HDMI
MUTE_H
TO SCALER
4
DCLK1
DVS
DHS
DVS
DHS
DB2
DB3
DB4
DB5
DB6
DB7
DB8
DB9
3
DCLK2
DVS
DHS
DEN
FROM REGULATOR
P.CON+5V
P.CON+1.5V
P.CON+3.3V
GND
0.1 B
R836 C887
1K
FROM JACK
0.01 B
C888
SPIF_134
SW_AUDIO_R[PC]
SW_AUDIO_L[PC]
2
PCBDS0
CEF156
21
W905
DR5
DR4
DR3
DR2
NR806
4D03WGJ0470T5E
0.001 B
B804
BLM18BB600SN1
22
SW_SCART
TO VIDEO ENHANCER
0.1 B
6
S_DET
DR9
DR8
DR7
DR6
C894
0.1 B
C897
NC NC NC
4SI_SDA_OUT
4SI_SDA_IN
4SI_SCL
DPB7
DPB6
DPB5
DPB4
DPB3
DPB2
DPB1
DPB0
C893
0.1 B
C813
4SI_CHIP_SE
DPR7
DPR6
DPR5
DPR4
DPR3
DPR2
DPR1
DPR0
6.3V 220
V-S
60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100 101 102 103 104 105 106 107 108
100YT05401
54MHz
W1014
C
10K
R831
107 DVDD18
57
X801
B
C886
0.1 B
0.1 B
106 QGL0
DVDD18
4SI_SCL
4SI_SDA_OUT
4SI_SDA_IN
4SI_CHIP_SE
A
0 NC
0 NC
0 NC
0 NC
0
0 NC
0 NC
0 NC
0 NC
3.3
0
1.8
DGND
56
BLM18BB600SN1
2.2
2.2
B
C7242
2.2
B
C7241
2.2 B
C7240
C7238
W883
2.2 B
C7239
W803
55
C856
1
SW_G/SW_Y
SW_R/SW_CR
SW_B/SW_CB
SW2_R/CR
SW2_G/Y
SW2_B/CB
SW_CVBS
SW_VIDEO_Y
HD/SCART_Y
R8J66607A72FP
NC
SCALER_RESET
FROM/TO AV SWITCH
IC801
B806
C810
2
SCALER
B
C892
0.1
SCALER_RESET
BLM18PG181SN1D
SCART1_SW
165 QBR4
C891
0.1
SCL1
DPG7
DPG6
DPG5
DPG4
DPG3
DPG2
DPG1
DPG0
P.CON+1.5V B805
27
0.1 B
0.1 B
0.1 B
216 DGND
0
0
NC
0
NC
0
NC
0
NC
0
3.3
0
NC
0
NC
0
NC
0
NC
0
NC
0
NC
3.3
GND
S_DET
S_DET
C836
C837
C838
DDHS
DDVS
DDCK
109 110 111 112 113 114 115 116 117 118 119 120 121 122 123 124 125 126 127 128 129 130 131 132 133 134 135 136 137 138 139 140 141 142 143 144 145 146 147 148 149 150 151 152 153 154 155 156 157 158 159 160 161 162
LCD-H/PDP_RLY
26
C824
0.1 B
SW_CVBS
C883 0.1 B
PDP_RLY
164 DVDD18
47
W874
163 DGND
215 DVDD18
R833
DVB_FAN_ON-H
214 PXD23
DCLK1
LCDON
DVB_FAN_ON-H
24
25
AFT_1[LOW]
DVDD33
QBR3
QBR2
QBR1
QBR0
DGND
DVDD33
QGR7
QGR6
QGR5
QGR4
QGR3
QGR2
DVDD33
DGND
DVDD18
QGR1
QGR0
QCLKR
QRL7
QRL6
QRL5
QRL4
QRL3
DVDD33
DGND
DVDD18
QRL2
QRL1
QRL0
QBL7
QBL6
QBL5
QBL5
QBL4
QBL3
QBL2
DVDD33
DGND
DVDD18
QBL1
QBL0
QGL7
QGL6
QGL5
DGND
DVDD33
QGL4
QGL3
QGL2
QGL1
TEST1
LPF1
TEST0
DVD33
0
0
3.3
3.3
1.8
C884 0.1 B 0
23
POWER_ON-H
AUDIO_MUTE
SDA1
W1010
POWER_ON-H
AFT_1
22
DCLK2
21
POWER_FAIL
0
0
0
3.3
0.1 B
0
C879 0.1 B
3.3
0
POWER_FAIL
470
DHS
DVS
DEN
20
DVDD33
PXD24
PDX25
PDX26
PDX27
VDIN
HDIN/FBIN
DVDD33
DGND
VRPD
VROD
VRMD
VIND
AVDDD2
AVSSD2
AVDDD1
AVSSD1
VRPC
VROC
VRMC
VINC
AVDDC2
AVSSC2
AVDCC1
AVSSC1
DVDD
DVSS
VRPB
VROB
VRMB
VIN1B
AVDDB2
VIN2B
AVSSB2
AVDDB1
AVSSB1
VRPA
VROA
VRMA
VIN1A
AVDDA2
VIN2A
AVSSA2
VIN3A
AVDDA1
AVSSA1
SVSS
DVDD33
DGND
RESET
QOECTL
HDIN2
VDIN2
DVDD33
55 56 57 58 59
HP_MUTE
FROM ADC
216 215 214 213 212 211 210 209 208 207 206 205 204 203 202 201 200 199 198 197 196 195 194 193 192 191 190 189 188 187 186 185 184 183 182 181 180 179 178 177 176 175 174 173 172 171 170 169 168 167 166 165 164 163
D
E
7PCH
19
3.4
3.4
3.4
3.4
3.4
3.4
3.4
3.4
0
1.6
1.2
0.7
0.9
3.4
0
3.4
0
1.6
1.1
0.7
1.3
3.4
0
3.4
0
3.4
0
1.6
1.1
0.7
0.5
3.4
2.0
0
3.4
0
1.6
1.1
0.7
0.5
NC
3.4
1.3
0
1.3
3.4
0
0
3.4
0
3.7
3.7
3.3
3.3
3.4
0.1 B
C875
DPR4
DPR5
DPR6
DPR7
DDVS
DDHS
SCART2_SW
SCART2_SW
C851
0.1 B
SCART1_Y
SCART1_Y
18
C822
R830
GND
17
6.3V 220
V-S
GND
C868
AFT_2[HIGH]
7
POWER_ON-H
STEREO_RESET
10K
16
W987
7PCH
GND
AFT_2/DTV_CVBS
C861
14
6.3V 220 V-S
C2801
6.3V 220 V-S
SCART1_R
SW2_R/CR
R817
R818 10K
10K R819
R820 10K
10K R821
R82210K
10K R823
13
20
3D_Y/C_656-CLK R804
47
GND
C2802
PXD22
PXD21
PXD20
PXD17
PXD16
PXD15
DVDDSD
PXD14
PXD13
PXD12
PXD11
PXD10
PXD07
PXD06
DVDD33
DGND
DVDD18
PXD05
PXD04
PXD03
PXD02
PXD01
PXD00
PXCLK
DVDDSD
DGND
QBLCD
QBLCC
QBLCB
QBLCA
TSTCLK
QRR7
QRR6
QRR5
QRR4
DVDD33
DGND
DVDD18
QRR3
QRR2
QRR1
DVDD33
DGND
DVDDSD
QRR0
QBR7
QBR6
QBR5
12
SW2_G/Y
MPWEL
MPOE
MPCE
MPAH/PCXLKI
DVDDSD
MDQ15/C656IN7
MDQ14/C656IN6
MDQ13/C656IN5
MDQ12/C656IN4
MDQ11/C656IN3
DVDD33
DGND
DVDD18
MDQ10/C656IN2
MDQ9/C656IN1
MDQ8/C656IN0
MDQ7/C656OUT7
MDQ6/C656OUT6
MDQ5/C656OUT5
MDQ4/C656OUT4
MDQ3/C656OUT3
MDQ2/C656OUT2
MDQ1/C656OUT1
DVDDSD
DGND
MPSEL0
XIN
XOUT
MPSEL1
MDQ0_C656OUT0
QE/PXCLK0
QH
QV
QDRVHA/QDE
DVDD33
DGND
DVDD18
QDRVHB
QDRVHC
QDRVHD
QDRVHE
DVDD33
DGND
DVDDSD
QDRVHF
QDRVVA
QDRVVB
QCLKL
SCART1_G
0
0.1 B
1.8
3.3
3.3
3.3
3.3
3.3
3.3
3.3
3.3
C853
3.3
0.1
B
3.3
3.3
3.3
3.3
C857
3.3
0.1 B
3.3
3.3
C860
0
0.1
B
3.3
3.3
3.3
3.3
3.3
3.3
3.3
B803 BLM18BB600SN1W810
3.3
3.3
0
C863
SW2_B/CB
54 53 52 51 50 49 48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33 32 31 30 29 28 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
19
0
1.8
3.3
3.3
3.3
3.3
3.3
3.3
3.3
3.3
3.3
C852 0.1 B 3.3
3.3
3.3
C855 0.1 B
0
1.8
3.3
C858 0.1 B 3.3
3.3
3.3
3.3
3.3
3.3
3.3
3.3
3.3
3.3
0
C862 0.1 B
R826 10K 0
1.8
1.8
R828
10K 0
R829
10K 0
3.3
R844
47 3.3
R845
47 3.3
3.3
3.3
0
C870 0.1 B
1.8
0
C872
11
18
EXT_MUTE-H
POWER_FAIL
0.1 B
SCART1_B
GND
1SS355
C849
GND
9
EXT_MUTE-H
6.3V 220
V-S
8
1SS355
B
EXT_MUTE-H
10
6
AFT
SCART2_SW
SCART1_Y
0.1
7
AUDIO_MUTE
D808
B802 ANALOG+3.3V
AUDIO_MUTE
BLM18PG181SN1D
6
HP_MUTE
D807
B801 DIGITAL+3.3V
HP_MUTE
BLM18PG181SN1D
W880
5
15
REMOCON_IN
SCART1_SW
4
7
DPG7
DPG6
DPG5
DPG4
AFT
DPB3
DPB2
DPB1
DPB0
3
REMOCON_IN
DPB7
DPB6
DPB5
DPB4
REMOCON IN
DPR3
DPR2
DPR1
DPR0
2
STANDBY_LED
STANDBY_LED
P.CON+3.3V
STANDBY LED
GND
1
NOTE:THE DC VOLTAGE AT EACH PART WAS MEASURED
WITH THE DIGITAL TESTER WHEN THE COLOR BROADCAST
WAS RECEIVED IN GOOD CONDITION AND PICTURE IS NORMAL.
NOTE: THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME
OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE
F
G
H
1
H-20
A
B
C
D
E
F
G
H
ADC SCHEMATIC DIAGRAM
8
8
(SCALER PCB)
FROM/TO MICON
SCL1
SDA1
7
7
DDHS
DDVS
DDHS
DDCK
C2136
0.1 B
3.9
3.9
0
0.5
0
C2137
0.1 B
0.1 B
C2145
0.9
C2143
0.5
4
C2132
0.1
B
R2109
0
40
0
R2108
BUFFER
Q2101
KTA1504S_Y_RTK
C2151
22uH
NLCV32T
100P CH
0.047 B
C2129
C2150
C2139
0.5
3.3
L2107
0.1 B
B
C2149
C2138
0.1
0
6.3V 220 V-S
0.1 B
FROM AV SWITCH
27
1K
3.3
0.001 B
0.047 B
0
3.3
5
100
0
220 V-S
C2131
120
R2110
3.3
C2133
6.3V
R2111
0.047 B
15uH
3.3
C2144
NLV25T
L2106
60
59
57
56
55
54
53
52
51
50
49
48
47
46
45
41
GND
CLAMP
VD
38
39
0 3.3
0.1 B
0.1 B
36
37
0 0.4
C2130
SW_PR/R
5.0
R2114
28
SW_Y/G
0.7
3
100
0
29
1K
GND
MIDSCV
PVD
32
33
34
35
0 1.3 1.3 3.3
C2124
28
29
30
31
0 3.3
3.8 3.8
0.0039 B
25
26
27
0 3.3 3.3
GND
24
0
COAST
21
22
23
0 3.3 3.3
GND
PVD
VD
FILT
BLUE0
VSYNC
BAIN
HSYNC
BLUE1
1.3
R2112
GND
3.3
120
GND
44
41
43
GND
42
21
BLUE2
58
VD
GND
VSOUT
SOGOUT
HSOUT
0.1 B
W1025
W967
R2104B2101
DATACK
VDD
GND
RED7
RED6
RED5
RED4
RED3
RED2
RED1
VD
0
SW_PB/B
6.3V 220 V-S
C2127
0.1 B
6.3V 220 V-S
C2121
0.1 B
C2113
0.1 B
22uH
NLCV32T
C2112
C2103
GND
6.3V 100 V-S
L2102
C2126
22uH
NLCV32T
P.CON+3.3V
2
C2125
100BLM18BB600SN1
DPR4
DPR5
DPR6
DPR7
NR2105
4D03WGJ0101T5E
RED0
VDD
BLUE3
C2120 R2103
L2101
VDD
1
2
3
4
5
6
7
8
9
VD
C2116
C2106
47uH
NLCV32T
FROM REGULATOR
BLUE4
L2103
DIGITAL
ANALOG
GND
1K
0
BLUE5
GND
3.3
GAIN
BLUE6
R2102
3.3
SOGIN
PVD
DPB7
DPB6
DPB5
DPB4
DPB3
DPB2
DPB1
DPB0
BLUE7
VD
GND
PVD
NR2104
4D03WGJ0101T5E
DPB3
DPB2
DPB1
DPB0
VDD
GND
3.3
VD
MST9883C-LF-110
GND
GND
3.3
GREEN0
0.1 B
3.3
AD CONVERTER IC
IC2101
VDD
DPR7
DPR6
DPR5
DPR4
DPR3
DPR2
DPR1
DPR0
3.3
GND
GREEN1
VDD
NR2103
4D03WGJ0101T5E
DPB7
DPB6
DPB5
DPB4
RAIN
C2111
3.3
GREEN2
0.1 B
3.3
A0
C2109
3.3
B
GND
GREEN3
10
0.1
61
SCL
11
C2105
DPG7
DPG6
DPG5
DPG4
DPG3
DPG2
DPG1
DPG0
REF BYPASS
GND
GREEN4
12
0
80
SDA
13
3.3
GREEN6
14
DDHS
DDVS
DDCK
3.3
VD
15
NR2102
4D03WGJ0101T5E
DPG3
DPG2
DPG1
DPG0
GND
16
3.3
6
0
61
GREEN5
17
3.3
3.3
FROM INTERFACE_HDMI
3
3.3
GREEN7
0 3.3
63
62
18
NR2101
4D03WGJ0101T5E
DPG7
DPG6
DPG5
DPG4
DPB7
DPB6
DPB5
DPB4
DPB3
DPB2
DPB1
DPB0
4
3.3
GND
0 3.1
65
64
19
3.3
20
0
DPR7
DPR6
DPR5
DPR4
DPR3
DPR2
DPR1
DPR0
5
0 3.0 3.1
68
67
66
0 3.3 3.3 3.3 3.3 3.3 3.3 3.3 3.3 3.3 3.3 3.3
80
79
78
77
76
75
74
73
72
71
70
69
6.3V 100 V-S
6
1
0.039 B 8.2K
DPG7
DPG6
DPG5
DPG4
DPG3
DPG2
DPG1
DPG0
0.1 B
C2110
DDHS
DDVS
DDCK
0.1 B
C2108
TO SCALER
23
NR2106
4D03WGJ0101T5E
DPR0
DPR1
DPR2
DPR3
DDVS
FROM JACK
2
R2106
R2115
VGAVS
33
VGAHS
33
P.CON+5V
PCBDS0
CEF156
NOTE: THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME
OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE
1
H-21
A
B
C
NOTE:THE DC VOLTAGE AT EACH PART WAS MEASURED
WITH THE DIGITAL TESTER WHEN THE COLOR BROADCAST
WAS RECEIVED IN GOOD CONDITION AND PICTURE IS NORMAL.
D
E
F
1
G
H
H-22
A
B
C
D
E
F
G
H
VIDEO ENHANCER SCHEMATIC DIAGRAM
(SCALER PCB)
DVS
DEN
DHS
DGO5
DGO4
DGO3
DGO2
8
DV1000_RESET
TO LVDS
NR7504
4D03WGJ0470T5E
NR7503
4D03WGJ0470T5E
DGO9
DGO8
DGO7
DGO6
8
FROM/TO MICON
DBO9
DV1000_RESET
C7511
47
7
SDA1
0.1 B
47
R7508
47
R7512
R7506
DBO4
0.1
C7506
DBO5
JG7507
DBO6
0.1
DBO7
JG7506
B
DBO8
B C7507
7
SCL1
DBO3
DBO2
DB9
DGO9
67
66
65
C7513
64
CLARITY_IN3
63
DB8
62
DB7
61
DB6
60
DB5
59
DB4
B_CB_CRCB_IN3
58
DB3
B_CB_CRCB_IN2
57
0.1 B
B_CB_CRCB_IN6
68 CLARITY_IN2
B_CB_CRCB_IN5
67 CLARITY_IN1
B_CB_CRCB_IN4
96 G_Y_OUT9
66 CLARITY_IN0
95 G_Y_OUT8
65 B_CB_CRCB_IN9
64 VCC_BUF
TEST_MODE3
B_CB_CRCB_IN1
63 B_CB_CRCB_IN8
TEST_OUT
B_CB_CRCB_IN0
TEST_IN
VCC_BUF
6
DB2
W872
55 56
B_CB_CRCB_IN7
W973
JG7513
JG7514
FROM SCALER
54
CLARITY_IN4
CLARITY_IN5
CLARITY_IN6
CLARITY_IN7
RESET_N_IN
VSS
VCC_CORE
HSYNC_IN
VSYNC_IN
FIELD_IN
TEST_IN
WINDOW_ENABLE_IN
SC_ADD_10BIT_7BIT_N_IN
G_Y_OUT0
G_Y_OUT1
VSS
VCC_BUF
VCC_CORE
G_Y_OUT2
G_Y_OUT3
G_Y_OUT4
VSS
G_Y_OUT5
68
5
VCC_CORE
VCC_CORE
53
C7514
DCLK2
PROCESS_CONTROL_IN
VSS
PROCESS_CONTROL_IN
SDA
B
DHS
52
0.1
R7510
B_CB_CRCB_OUT0
VCC_BUF
B_CB_CRCB_OUT1
VSS
R_CR_OUT9
51
50
49
48
R_CR_OUT8
B_CB_CRCB_OUT2
R_CR_OUT7
43
B_CB_CRCB_OUT3
R_CR_OUT6
R_CR_OUT5
VCC_BUF
2 R_CR_IN1
G_Y_IN7
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
1 R_CR_IN0
B_CB_CRCB_OUT7
B_CB_CRCB_OUT8
1
2
31 G_Y_IN8
G_Y_IN6
B_CB_CRCB_OUT6
R_CR_OUT3
38
32 G_Y_IN9
R_CR_OUT2
37
127 B_CB_CRCB_OUT9
VCC_CORE
VCC_BUF
31
36
VSS
R_CR_OUT4
35
33 R_CR_OUT0
2
DB7
DB6
DB5
DB4
DB3
4
DB2
DG9
NR7505
4D03WGJ0470T5E
DG8
DG7
DG6
DG5
DRO5
DRO4
DRO3
DRO2
C7512
0.1
DG4
DG3
DG2
NR7506
4D03WGJ0470T5E
DR9
B C7516
34
128 VSS
1
NC
DRO9
DRO8
DRO7
DRO6
0.1 B
JG7511
33
34 R_CR_OUT1
B_CB_CRCB_OUT5
3
40
VSS
4
39
B_CB_CRCB_OUT4
DB9
DB8
B
X7501
100DT02006
20MHz
B
0.1
41
VCC_CORE
42
VSS
0.1
C7515
47
OUTPUT_ENABLE_N_IN
HBLANK_IN
100
C7518
46
CLK_SYSTEM
DVS
DEN
SCL1
45
SCL
VIDEO_ENHANCER IC
IC7501
DV1000-75
VBLANK_IN
SDA1
100
R7509
44
CLK_VIDEO
VSS
NR7502
4D03WGJ0470T5E
69
G_Y_IN5
3
70
G_Y_IN4
DBO6
DBO7
DBO8
DBO9
71
G_Y_IN3
0.1 B
72
G_Y_IN2
C7504
73
G_Y_IN1
NR7501
4D03WGJ0470T5E
74
G_Y_IN0
DBO2
DBO3
DBO4
DBO5
75
VCC_CORE
0.1 B
76
VCC_BUF
C7503
TEST_MODE2
77
HSYNC_OUT
JG7503
TEST_MODE1
78
VSYNC_OUT
W854
B7501
BLM18BB600SN1
4
JG7502
97 SC_ADD_CTRL_IN
TEST_MODE0
79
WINDOW_ENABLE_OUT
DVS
DENO
98 SC_ADD_CTRL_IN
SC_ADD_CTRL_IN
80
VSS
0.1 B
SC_ADD_CTRL_IN
81
FIELD_OUT
DHS
SC_ADD_CTRL_IN
82
HBLANK_OUT
0.1 B C7505
83
VBLANK_OUT
DRO2
84
VCC_BUF
JG7501
C7502
DRO3
85
R_CR_IN9
DRO4
86
R_CR_IN8
DRO5
87
R_CR_IN7
W869
DRO6
88
R_CR_IN6
DRO7
89
R_CR_IN5
DRO8
90
VSS
W870
DRO9
91
R_CR_IN4
DGO2
92
R_CR_IN3
128 127 126 125 124 123 122 121 120 119 118 117 116 115 114 113 112 111 110 109 108 107 106 105 104 103 102 101 100 99
W871
DGO4
93
G_Y_OUT6
97
DGO5
DGO3
5
94
98
DGO6
6
95
G_Y_OUT7
96
DGO7
R_CR_IN2
DGO8
JG7512
3
DR8
DR7
DR6
DR5
DR4
32
DR3
B7502
C7521
6.3V 47 V-S
C7519
6.3V 47 V-S
W975
W974 0.1 B
0.1 BC7510
33 R7507
C7509 33
R7505 33
BLM18PG181SN1D L7502
R7513
C7508
2
0.1 B
JG7505
W989
W988
JG7504
DR2
JG7515
JG7508
JG7500
FROM REGULATOR
47uH
NLCV32T
P.CON+1.8V
2
P.CON+3.3V
GND
DG9
DG8
DG7
DG6
DG5
DG4
DG2
DG3
JG7509
DR9
DR8
DR7
DR6
DR5
DR4
DR3
DR2
DCLK2
DHS1
JG7510
DENO
DVS1
PCBDS0
CEF156
1
1
NOTE: THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME
OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE
H-23
A
B
NOTE:THE DC VOLTAGE AT EACH PART WAS MEASURED
WITH THE DIGITAL TESTER WHEN THE COLOR BROADCAST
WAS RECEIVED IN GOOD CONDITION AND PICTURE IS NORMAL.
C
D
E
F
G
H
H-24
A
B
C
D
E
F
G
H
LVDS SCHEMATIC DIAGRAM
(SCALER PCB)
8
8
TxOUT1-
TxIN13
TxOUT1+
GND
LVDSVcc
TxIN14
LVDSGND
TxIN15
TxOUT2-
DGO9
DGO8
DGO7
DGO6
DGO5
DGO4
DGO3
DGO2
DBO3
3.3
DBO5
3.3
DBO6
3.3
0
DRO9
DRO8
DRO7
DRO6
DRO5
DRO4
DRO3
DRO2
DBO7
3.3
DBO8
3.3
DBO9
DHS1
DVS1
DENO
3.3
TxIN16
R-FB
TxCLKOUT-
TxIN17
TxCLKOUT+
TxIN18
TxOUT3TxOUT3+
TxIN19
GND
LVDSGND
TxIN20
PLLGND
TxIN21
PLLVcc
PLLGND
TxIN22
SDA2
SCL2
DHS1
3.3
DVS1
3.3
POWER_ON-H
3
56
55
54
53
52
51
50
49
48
32
TxCLKIN
Vcc
TxIN24
TxIN25
TxIN26
GND
3.3
DRO4
3.3
DRO2
0
1.3
NR7204
4D03WGJ0220T5E
6
PDP_TXOUT0PDP_TXOUT0+
PDP_TXOUT1PDP_TXOUT1+
1.2
1.3
1.2
C7227
3.2
0
1.2
NR7203
4D03WGJ0220T5E
5
PDP_TXOUT2PDP_TXOUT2+
PDP_TXCLKOUTPDP_TXCLKOUT+
1.2
24
1.3
1.3
R7206
1.2
22
R7207
PDP_TXOUT3PDP_TXOUT3+
0
3.3
31
3.3
DRO5
C7226
PDP_TXOUT0-
0.1 B
PDP_TXOUT0+
0
PDP_TXOUT1PDP_TXOUT1+
3.3
PDP_TXOUT22.8
W882
B7202
DCLK1
BLM18BB600SN1
PDP_TXOUT2+
PDP_TXCLKOUT-
3.3
DENO
PDP_TXCLKOUT+
PDP_TXOUT3-
0
C7229
PDP_TXOUT3+
0.1 B
C7222
L7201
R7201
6.3V 220 V-S
C7202
FROM REGULATAR
0.1 B
C7203
0.1 B
C7201
0.1 B
2
R7210
P.CON+3.3V
4.7K
180
P.CON+3.3V
330
2
RXIN0+
3
RXIN1-
4
RXIN1+
5
GND
6
RXIN2-
7
RXIN2+
8
RXCLK IN-
9
RXCLK IN+
10
RXIN3-
11
RXIN3+
12
GND
13
GND
14
NC
15
NC
NC
16
NC
NC
17
NC
NC
18
GND
19
NC
NC
20
NC
NC
21
NC
NC
22
NC
NC
23
RXIN4-
24
RXIN4+
25
4.7K
W889
W835
NC
V-S
C7219
4V
V-S
V-S
C7209
SCL2
6.3V 220
47uH
NLCV32T
C7208
47uH
NLCV32T
POWER_ON-H
SDA2 W834
6.3V 220
L7203
L7202
RXIN0-
NC
R7211
47uH
NLCV32T
4
PDP_L
CP7202
FI-TWE31PB-VF
1
GND
0
30
FROM/TO MICON
7
22
PWRDWN
TxIN23
3.3
1.3
29
NC
DRO6
0
0.1 B
0
25
4
TxOUT2+
16
0
17
DBO2
3.3
18
3.3
19
DBO4
20
DBO9
DBO8
DBO7
DBO6
DBO5
DBO4
DBO3
DBO2
3.3
26
5
DGO9
21
FROM VIDEO ENHANCER
22
0
23
DCLK1
24
DVS
27
DVS
DHS
28
DHS
47
TxIN12
FROM SCALER
46
10
3.3
TxOUT0+
11
DGO8
TxIN11
12
3.3
13
DGO7
14
3.3
15
DGO3
45
TxOUT0-
44
Vcc
0.1 B
43
LVDSGND
42
1
2
3
TxIN10
DRO7
3.3
41
3.3
TxIN27
40
C7218
6
TxIN9
39
3.3
TxIN0
38
DGO2
TxIN8
37
3.3
TxIN1
36
DGO6
GND
DRO8
3.3
35
3.3
GND
TxIN7
3.3
34
DGO5
TxIN2
TxIN6
33
0
TxIN3
4
DGO4
3.3
TxIN5
5
DRO9
3.3
6
DRO3
3.3
TxIN4
RS
7
3.3
8
W830
9
7
0.1 B
C7221
LVDS IC
IC7202
PDP_L/LCD_ALL ICSV385AGLFT
GND
26
DISPEN
27
I2C SDA
28
I2C SCL
29
NC
30
GND
31
3
2
PCBDS0
CEF156
GND
1
H-25
NOTE: THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME
OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE
A
B
PIECES REPAREES PAR UN
ETANT
ATTENTION:LES
DANGEREUSES AN POINT DE VUE SECURITE
NOTE:THE DC VOLTAGE AT EACH PART WAS MEASURED
WITH THE DIGITAL TESTER WHEN THE COLOR BROADCAST
WAS RECEIVED IN GOOD CONDITION AND PICTURE IS NORMAL.
C
D
THESE PARTS MARKED BY
CAUTION:SINCE
CRITICAL FOR SAFETY,USE ONES
N’UTILISER QUE CELLS DECRITES
DANS LA NOMENCLATURE DES PIECES
E
F
ARE
1
DESCRIBED IN PARTS LIST ONLY
G
H
H-26
A
B
C
D
E
F
G
H
JACK SCHEMATIC DIAGRAM
(SCALER PCB)
8
8
FROM INTERFACE_HDMI
DVI_A_IN_L
DVI_A_IN_R
HDMI_A_IN_L
HDMI_A_IN_R
W891
PC_A_IN_R
TO SCALER
SPIF_134
SW_AUDIO_R[PC]
YUV/HDMI/DVI Rch SW
7
IC4305
7
SW_AUDIO_L[PC]
NJM2534V
0
4.7
1B
W892
BUFFER
3
5
DGND
6
AGND
7
AGND
8
AGND
9
NC
10
DGND
6
9.1
5
8
0
7
4.5
5.2
4.8
C4324
16V100 V-S
180K
R4328
TO ADC
VGAVS
C4378
4.7K
470P CH
C4372
470P CH
26
KEY-B
KEY-A
D4301
VGA-R
BLM18BB600SN1
10K
B4305
NC
NC
DDCD
NC
13
VGAHS
14
VGAVS
15
DDCC
CP2200
(CD2200)
A2001WV2-3P
GND
1
KEY B
2
KEY A
3
4
UDZS5.6B
BLM18BB600SN1
VGA-B
FROM REGULATOR
10K
P.CON+9V
GND
NC
12
FROM OPE/REMOCON/CHOKECOIL
UDZS5.6B
D4302
VGA-G
R4316
11
5
VGAVS
2.4
R4333
R4324
C4366
0.001 B
VGA-B
1B
25
PC_A_IN_L
PC_A_IN_R
0.001
R4315
NC
R4310
NC
VGA-G
C4357
75
VGA-B
4
VGA-R
6
9.1
BAIAS
10K
B4304
75
3
BUFFER
Q4305
KTC3875S_Y_RTK
TO AV SWITCH
5.4
BLM18BB600SN1
R4309
R4305
VGA-G
B4303
75
R4308
4
2
B
C4362
D-SUB
CP4302
1-1734344-1
VGA-R
1
3.0
3.0
1 B
R4320
1K
MMZ1608R102CT
C4314
R4329
R4313
8.5
220K
B4308
8.5
BUFFER
Q4302
KTC3875S_Y_RTK
4.7K
RED
R
180K
R4319
3
E
5
220K
H1
2
1 B
NC
1
1K
MMZ1608R102CT
SW_AUDIO_L[PC]
5
C4315
5.2
4.8
1
2
1B
COMPONENT/HDMI
22uH
4.6
3
DVI_A_IN_L
4
H2
C4351
4
R4314
6
KEY-B
BUFFER
4.8
DVI_A_IN_R
B4307
DVD_TX
C4350
1B
P.CON+9V
HDMI/DVI
1B
KEY-A
HDMI/DVI
NLV32T
L4306
COMPONENT/HDMI
C4358
YUV/HDMI/DVI Lch SW
IC4304
NJM2534V
HDMI_A_IN_R
HDMI_A_IN_L
AUDIO IN(DVI1/PC)
J4301
MSD-242VA1-03_NI_FE_LF
WHITE L
FROM/TO MICON
DVD_RX
4.7
C4337
16V 100 V-S
6
0.1 B
47uH
NLC3225
C4328
L4301
P.CON+9V
SW_AUDIO_R[PC]
4.5
4.8
BAIAS
4
1B
4.6
3
C4353
7
2
PC_A_IN_L
8
1
C4352
R4304
VGAHS
R4323 10
10
VGAVS
3
NC
2
2
PCBDS0
CEF156
1
H-27
A
B
C
1
NOTE:THE DC VOLTAGE AT EACH PART WAS MEASURED
WITH THE DIGITAL TESTER WHEN THE COLOR BROADCAST
WAS RECEIVED IN GOOD CONDITION AND PICTURE IS NORMAL.
NOTE: THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME
OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE
D
E
F
G
H
H-28
A
B
C
D
E
F
G
H
AV SWITCH SCHEMATIC DIAGRAM
SW2_G/Y
8
8
(SCALER PCB)
W1016
SW2_G/Y_1
R8105
SW_G/SW_Y
SW_Y/G
SW2_B/CB
1K
R8146
1K
R8143
270
SW_PB/B
SW_PR/R
W1017
SW2_B/CB_1
7
7
6
0
B
C8150
6
R8124
SW_R/SW_CR
FROM JACK
0.7
100
P.CON+5V
22uH
0.1
SW2_R/CR
BUFFER
Q8105
KTA1504S_Y_RTK
C8149
5.0
R8145
6.3V 220 V-S
W1018
NLCV32T
L8105
0
270
SW2_R/CR_1
BUFFER
Q8106
KTA1504S_Y_RTK
0.7
100
C8151
R8148
R8122
SW_B/SW_CB
100P CH
5.0
270
VGA-G
VGA-R
VGA-B
FROM/TO MICON
C_SYNC
C_SYNC_POP
SD_SW1
W963
YUV_SW
SW2_B/CB_1
OUT3
IN2A
OUT2
CTL
2.6
SW2_G/Y_1
1M
16V 10 V-S-NP
W972
1M
9
10
0
W964
SW2_R/CR_1
C8123
OUT1
IN2B
NC
GND1
V+
12
13
4
GND2
3
0
2
16V 10 V-S-NP
1.8
0
YUV_SW
NLCV32T
L8104
P.CON+5V
3.2
IN1A
IN1B
16V 10 V-S-NP
C8126
1M
16V 10
V-S-NP
C8125
16V 47 V-S
15
2.6
1M
2.6
16
C8120
0
1
NC
C8124
2.8
R8121 R8120
0
1M
R8114
W971
NC
14
47uH
2
4
GND3
C8122
2.2
R8118 R8117
1.6
NC
11
0
NC
IN3B
6
HD/SCART_Y
SW_VIDEO_Y
SW_R/SW_CR
SW_G/SW_Y
SW_B/SW_CB
SW2_R/CR
SW2_G/Y
SW2_B/CB
SW_CVBS
1M
R8115
16V 10 V-S-NP
IN3A
5
FROM/TO SCALER
1.8
8
5
C8121
7
5
4
VGA-R
VGA-B
16V 10 V-S-NP
SW
NJM2584AM(TE1)
IC8104
W944
TO ADC
W900
W843
VGA-G
P.CON+5V
SW_Y/G
SW_PB/B
R8131
SW_PR/R
FROM REGURATER
3
1K
3
GND
B
0.7
0
12K
C8147
B
R8128
0.1 B
1
SYSNC_SEPA
Q8103
KTC3875S_Y_RTK
3.1
0.3
C8146
C8144
2.7K
12K
820P CH
1.5 R8125
R8123
820K
5.5
C8137
1K
4.7K
Q8101
5.1
KTA1504S_Y_RTK
330P CH
R8119
C8131
16V 100 V-S
1 B
R8113
100K
SD_SW1
1
R8116
47uH
NLCV32T
5.1
3.3K
SYSNC_SEPA
C_SYNC
R8130
0
2
SYSNC_SEPA
Q8102
KTC3875S_Y_RTK
P.CON+9V
L
1.0
R8129
C8128
L8102
3
0
BUFFER
6
B
4.4
C8110
SW_CVBS
SW_VIDEO_Y
1
8.9
2
0
B
C8113
2
VCC
5
1
H
5.1
1
4
C8112
1 B
C8109
C8129
SCART2 OUT CVBS SW
IC8103
MM1501XNRE
P.CON+5V
0.1 B
AT+5V
P.CON+9V
PCBDS0
CEF156
H-29
NOTE:THE DC VOLTAGE AT EACH PART WAS MEASURED
WITH THE DIGITAL TESTER WHEN THE COLOR BROADCAST
WAS RECEIVED IN GOOD CONDITION AND PICTURE IS NORMAL.
NOTE: THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME
OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE
1
A
B
C
D
E
1
F
G
H
H-30
A
B
C
D
E
F
G
H
REGULATOR SCHEMATIC DIAGRAM
(SCALER PCB)
8
8
5
P.CON+3.8V
6
P.CON+3.8V
7
GND
8
GND
9
GND
10
HDMI5V
11
AT+5V
470P CH
P.CON+5V
GND
BLM18PG181SN1D
TO SCALER
GND
B3206
BLM18PG181SN1D
P.CON+5V
P.CON+3.3V
P.CON+1.5V
GND
B3207
6
P.CON+3.3V
AT+3.3V
BLM18PG181SN1D
B3203
W857
P.CON+5V
AT+3.3V
TO ADC
P.CON+5V
470P CH
4
7
P.CON+9V
C3203
3
B3201
B3205
BLM18PG181SN1D
B3202
BLM18PG181SN1D
470P CH
C3205
P.CON+9V
C3201
P.CON+12V
2
470P CH
1
470P CH
C3207
C3204
CP3201 (CD3807)
A2001WV2-11P
7
470P CH
C3206
FROM/TO POWER
AT+5V
BLM18PG181SN1D
6
1.5V_REG
IC3202
3.3V_REG IC
IC3201
BA00BC0WFP
FROM/TO MICON
BD7820FP
SCALER-H
10K
AT+3.3V
AT+5V
P.CON+5V
0.7
R3221
HDMI_H
GND
1K +-1%
P.CON+1.5V
EC31QS04
R3222
3.9K
+-1%
1.6
D3206
EC31QS04 EC31QS04
R3216
R3212
220
P.CON+3.3V
D3207
0
10 +-1% 1K +-1%
10K
D3212
R3238
C3213
1 F
C3211
5
R3220
SCALER-H
6.8K
+-1%
1 F
C3212
W859
1.2
R3211
2.8
5
R3237
3.3
2.7
4
C3217
0
5
6
6.3V 100 V-S
4.1
4
2
GND V_OUT V_ADJ
1 F
2.7
6
1
C3216
2
V_IN
1 F
C3215
1
GND V_OUT V_ADJ
330
V_IN
330
R3217
V_C
6.3V 100 V-S
R3209
P.CON+3.3V
V_C
TO LVDS
5
P.CON+3.3V
GND
TO JACK
P.CON+9V
GND
1.8V_REG IC
IC3203
TO INTERFACE_HDMI
BD7820FP
HDMI+5V
4
HDMI_VNREG+5V
4
GND
R3232
V_C
V_IN
1
2
2.7
GND V_OUT V_ADJ
6
2.8
0
4
1.6
5
0.7
R3234
10K
680
+-1%
P.CON+1.8V
TO AV SWITCH
P.CON+9V
P.CON+5V
10
C3224
1 F
HDMI_VNREG+5V
6.3V 100 V-S
3
1 F
C3223
C3222
W860
R3235
1K
+-1%
D3209
EC31QS04
R3236
D3208
EC31QS04
3
AT+5V
GND
10K
R3244
10K
R3246
AT+3.3V
3.3
5
0
0
SW
Q3206
KRC102SRTK
10K 0.6
TO VIDEO ENHANCER
0
P.CON+1.8V
0
P.CON+3.3V
GND
2
2.2
B
W1007
2.2
B
C3219
0
C3218
1.8
HDMI_H
SW
0
Q3210
KTC3875S_Y_RTK
RXT_RST#
SW
Q3211
KTC3875S_Y_RTK
W1013
R3228
W1015
8.2K
R3224
R3245
1K
2
HDMI+5V
SW
4.3 Q3205
2SB1132
22K
R3223
5
PCBDS0
CEF156
1
H-31
NOTE: THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME
OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE
A
B
PIECES REPAREES PAR UN
ETANT
ATTENTION:LES
DANGEREUSES AN POINT DE VUE SECURITE
NOTE:THE DC VOLTAGE AT EACH PART WAS MEASURED
WITH THE DIGITAL TESTER WHEN THE COLOR BROADCAST
WAS RECEIVED IN GOOD CONDITION AND PICTURE IS NORMAL.
C
THESE PARTS MARKED BY
CAUTION:SINCE
CRITICAL FOR SAFETY,USE ONES
N’UTILISER QUE CELLS DECRITES
DANS LA NOMENCLATURE DES PIECES
D
E
ARE
CAUTION: DIGITAL TRANSISTOR
1
DESCRIBED IN PARTS LIST ONLY
F
G
H
H-32
A
B
C
D
E
F
G
H
INTERFACE_HDMI IC SCHEMATIC DIAGRAM
8
8
(SCALER PCB)
D3605
TO ADC
220K
RXT0_RST
6.3V 22 V-S
3.3
HDMI_VNREG+5V
3.3V_REG IC
IC3602
BA00BC0WFP
GND
NR3601
4D03WGJ0000T5E
1.8
FROM MICON
C3712
0
C3626
6
5.0
0
4
5
3.3
5
1.4
TO SCALER
3.3
0.1 F
+-1%
R3707
220 3.9K
0.1 F
R3706
C3658
6.3V 220 V-S
C3649
1.8V_REG IC
IC3601
TO JACK
DVI_A_IN_R
DVI_A_IN_L
HDMI_A_IN_R
BD7820FP
HDMI_A_IN_L
220
3.3
MUTE_H
6.8K
+-1%
R3705
3.3
C3645
NR3603
4D03WGJ0000T5E
NR3604
4D03WGJ0000T5E
DPG4
DPG5
DPG6
DPG7
D3628
0.001 B
EC31QS04
C3711
D3629
3.3
EC31QS04
3.3
C3653
31
DPG0
DPG1
DPG2
DPG3
3.3
3.3
2
GND V_OUT V_ADJ
R3708
3.3
1.8
0
1
2.8
NR3602
4D03WGJ0000T5E
0.001 B
V_IN
6.3V 100 V-S
3.3
V_C
0.1 F
3.3
HDMI_H
DPB4
DPB5
DPB6
DPB7
0.001 B
3.3
C3634
0
3.3
4
B3605 DDCK
BLM18BB600SN1
0.001 B
3.3
3.3
3.3
C3708
3.3
0.001 B
C3615
DPR4
DPR5
DPR6
DPR7
3.3
4
0
5
1.9
0.7
R3704
R3701
220
1K
+-1%
NR3605
4D03WGJ0000T5E
FROM/TO HDMI MICON2
SW
CSDA
HDMI_H
3.3
NR3606
4D03WGJ0000T5E
6
4.5
680 +-1%
0
2.8
GND V_OUT V_ADJ
10
C3709
2
0.1 F
R3703 R3702
3.3
V_IN
1
6.3V 100 V-S
C3635
3.3
V_C
C3659
32
DPR0
DPR1
DPR2
DPR3
3.3
C3657
3.3
0.1 F
120
W1023
R3689
6.3V 100 V-S
0.001 B
0.1 F
3.3
0
W1022
C3710
3.3
C3627
3.3
HSYNC
Q23
OGND
CLK48B
GND
VCC
INT
RESET#
Q22
SCDT
R1X2-
TEST
Q21
109 110 111 112 113 114 115 116 117 118 119 120 121 122 123 124 125 126 127 128 129 130 131 132 133 134 135 136 137 138 139 140 141 142 143 144
3.2
OGND
VSYNC
0
3.3
OVCC
3.3
DACOVCC
3.3
DACAVCC
0
3.3
0
RSET
VREF
COMP
DACGNDR
AnRPr
DACAGND
Q20
AVCC
03.2 3.4 3.3 3.3 0 NC 0 3.3 3.3 2.9 1.8
01.7
3
CSCL
H_INT
0
B3613
0.1 F
C3707
C3706
16V 10 V-S
1M
16V 10 V-S
R3698
VDD3
HCB2012K-600T25
DDVS
B3604
0.1 F
C3705
0 1.8 0 NC1.8
C3704
0
16V 10 V-S
03.3 3.3 3.3 3.3 3.3 3.3
C3703
0
16V 10 V-S
0
C3702
0
33
0 1.8
R3700
03.3 3.2
4.7K
0 1.8
0.1 F
C3611
C3612
DACVCCR
VCC
C3690
0.1 F
DACGNDG
DACVCCG
AnGY
DACGNDB
AnBPb
DACVCCB
DACDGND
DACDVCC
GND
VCC
R1X1+
F
10V 47 V-S
0
3.3
3.3
1.8
1.8
0
OGND
OVCC
GND
AGND
R3713
10 B
C3600
0.1 F
C3654
0.1 F
C3625
C3620
0.001 B
C3610
0.1 F
C3618
0.001 B
C3719
82 +-1%
+-1%
C3616
0.01 B
100
0
ANRPR
JG3602
16V10 V-S
R3622
0.01 B
R3651
3.3
C3632
0.001 B
0
3.3
C3619
C3716
0.001 B
0
0
C3715
0
0.1 F
0
0.001 B
JG3603
C3713
SW
RXT1_RST
JG3604
ANBPB
ANGY
220K
C3685
10 B
R3680
C3608
0
0
0.001 B
0.001 B
C3714
3.3
3.3
3.1
3.1
3.1
3.1
3.3
CSDA
CSCL
DSDA1
DSCL1
DSDA0
DSCL0
R1X1-
43
44
DVI_A_IN_R
4.7K
W968
R3638
CSCL
CSDA
C3617
10K
3.2
3.2
Q19
3.3
HDMI+5V
73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100 101 102 103 104 105 106 107 108
0.1 F
C3688
0.1
R1PWR5V
R0PWR5V
AVCC
HCB2012K-600T25
SCK
WS
SDO
H_INT
2.5 D
2
G 3.3
BUFFER
Q3607
S
KTK5132E 2.1
R3678
4.7K
B
C
1
NOTE:THE DC VOLTAGE AT EACH PART WAS MEASURED
WITH THE DIGITAL TESTER WHEN THE COLOR BROADCAST
WAS RECEIVED IN GOOD CONDITION AND PICTURE IS NORMAL.
NOTE: THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME
OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE
A
4.7K
4
3
2
10K
0.01 B
R3711
0.001 B
Q18
3.3
RX_INT
C3686
DVI_A_IN_L
CH
100P
AGND
C3689
BUFFER
Q3614
KTC3875S_Y_RTK
5.4
Q17
R1X2+
6
PCBDS0
CEE156
1
H-33
3.0
Q16
R1X0+
30
DPB0
DPB1
DPB2
DPB3
B
C3648_1
1 B
R1X0-
109 OVCC
DDVS
DDHS
DDCK
0.001
C3652
C3629_1
100P CH
1K
OGND
W1012
R3634 C3651
MMZ1608R102CT
ODCK
AVCC
0.1 F
BUFFER
Q3621
KTC3875S_Y_RTK
2.4
OVCC
AGND
73 DGND
33 DDHS
DPR0
DPR1
DPR2
DPR3
DPR4
DPR5
DPR6
DPR7
B3603
HCB2012K-600T25
3.3
0.001 B
B3621
8.5
3.0
R1XC+
RX_INT
C3701
L
1 B
8.5
Q15
JG3612
1K
MMZ1608R102CT
P.CON+9V
22uH
NLCV32T
R1XC-
AGND
33 DDVS
R3617
3.3
RXT_RST#
R3633 C3650
R
3
2
C3687
B3622
R3681
L
0
C3656
L3623
HDMI AUDIO IN
J3601
MSJ-2000B_AG(O87)
1
2
3.3
L3605
ACM2012D-900-2P
Q14
NC
3
3.3
AVCC
XTALVCC
4
2
3.3
3
0.001 B
HDMI CONNECTOR
CP3603
DC1R019JDA
R
C3655
2
Q13
REGVCC
D2+
0
R3684
D2-S
1
3.3
4
ANTSTO
Q12
XTALIN
1
3.3
PVCC1
XTALOUT
1
L3606
ACM2012D-900-2P
D2-
2
0.001 B
16V100 V-S
D1-S
D1+
3.3
GND
HDMI_I/F
IC3605
SiI9021CTU
DGND2
D1-
3
1K
6
2
180K
D0+
L3607
ACM2012D-900-2P
220K
7
C3630
R3686
D0-S
0
4
R3687
8
1
3.3
3.3
1K
D0-
3
R3683
9
2
0.001 B
L3608
ACM2012D-900-2P
180K
CLK+
R3635
CLK-S
10
4
220K
11
1
PGND
C3695
CLK-
3.3
VCC
AGND
C3693
0.001
33
B 18P CH
C3694
C3696
18P CH C3697
0.1 F
C3698
0.01 B
R3699
0.01 B
C3628
Q11
NC
0
AVRL161A1R1NT
Q10
R0X2+
DVCC2
NC
R0X2-
0.001 B
NC
CEC
3.3
3.3
B3602
NC
13
4
0.001 B
D3626
14
5
3.3
Q9
X3602
100DT02801
28.322MHz R3697
10
0.001 B
C3624
Q8
AVCC
VCC
SCL
3.3
AGND
C3700
15
AVRL161A1R1NT
0.1 F
C3605
Q7
0.001 B
SDA
JG3608
OVCC
R0X1+
33
C3692
16
D3627
R0X1-
33
GND
OGND
C3691
17
3.3
HCB2012K-600T25
C3613
POWER
3
0
B
3
R3610
18
12
0
C3607
0.001
4
DET
AVCC
GND
3.3
Q6
33
0.001 B
3
AGND
OGND
3.3
Q1
Q5
MCLK R3629
2
C3623
R3669
7
FROM REGULATOR
Q0
GND
OVCC
0
4
DPG0
DPG1
DPG2
DPG3
DPG4
DPG5
DPG6
DPG7
100K
JG3613
VCC
1 DE
36 DGND
SCK R3625
1
1
R0X0+
MCLKOUT
3.3
R0X0-
MCLKIN
3.3
2
35 DVCC
AVCC
R3696
0.001 B
3
Q4
WS
3.3
4
Q3
33
C3622
5
AGND
SCK
0
3
6
R0XC+
WS R3626
2
1.8
0
3.3
L3602
ACM2012D-900-2P
L3604
ACM2012D-900-2P
3.3
7
Q2
33
0.001 B
8
R0XC-
SD1/NC
0.1 F
4
AVCC
SD0
3
3.3
PVCC0
JG3611
C3621
1
L3603
ACM2012D-900-2P
2
3.3
0
C3606
3
4
0.01 B
R3695
C3721
C3720
0.001 B
3.3
L3601
ACM2012D-900-2P
1
0.1 F
C3718
4
3
2
1
C3717
3.3
4
2
3.3
3.3
19
1
5
6
7
470K
8
C3602
33
D2+
16V 10 V-S
SDO R3627
1
C3609
0.001
B
1
0
100K
36 35 34 33 32 31 30 29 28 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9
SD2/NC
D2-S
C3604
HCB2012K-600T25
JG3610
D2-
2
EEP_ROM IC
IC3609
BR24L02F-WE2
0
R3714
3.3
SW
Q3619
KTC3875S_Y_RTK
R3679
3.3
DPB0
DPB1
DPB2
DPB3
DPB4
DPB5
DPB6
DPB7
B3601
SD3/NC
3
R3710
D
JG3609
D1+
3.3
GND
D1-S
4
G
0
0.001 B
5
0
VCC
D1-
A0
BUFFER
Q3617
KTK5132E
MUTEOUT
6
A1
VCC
S
5.0
RSPDIF
D0+
WP
0
0.001 B
7
A2
D
JG3601
D0-S
4.8
GND
SCL
3.3
MUTE_H R3712
D0-
8
0
0
C3699
CLK+
9
0
OVCC
CLK-S
0
OGND
CLK-
11
A0
BUFFER
Q3618
KTK5132E
NC
12
10
4.9
SDA
NC
CEC
VCC
0
DVCC
13
4.8
47
NC
A1
0.1 F
SCL
47
WP
0
0.001 B
C3614
SDA
15
BUFFER
Q3615
S KTK5132E
3.2
3.3
0
R3709
10
A2
72 71 70 69 68 67 66 65 64 63 62 61 60 59 58 57 56 55 54 53 52 51 50 49 48 47 46 45 44 43 42 41 40 39 38 37
16
2.9
5
GND
D 5.0
6
POWER
17
G
7
18
14
5
R3601
S
5.0
8
DET
GND
SCL
SW
Q3613
KTC3875S_Y_RTK
3.3
W852
2.2K
19
R3685
6
470K
3.3 G
HDMI CONNECTOR
CP3601 DC1R019JDA
BUFFER
Q3616
S KTK5132E
3.2
470K
R3690
0.1 F
4.9
SDA
D 5.0
3.3 G
1K
R3716
C3722
1K
R3621
AVRL161A1R1NT
2.2K
EEP_ROM
BR24L02F-WE2
2.2K
47
0
R3688
47
R3606
47K
R3605
R3607
5.0
R3630
2.2K
AVRL161A1R1NT
D3603
47K
R3693
0.1 F
D3601
R3694
7
R3608
UDZS5.6B
C3633
IC3606
5.0
G3.3
BUFFER
S 3.2
Q3604
KTK5132E
470K
UDZS5.6B
5.0 D
R3609
D 5.0
G
3.3
BUFFER
3.2 S Q3603
KTK5132E
D3602
R3692
D3604
RB160L-40
D3600
D3630
RB160L-40
VDD5_PS
R3600
RB160L-40
D
E
F
G
H
H-34
A
B
C
D
E
F
G
H
HDMI MICON2 SCHEMATIC DIAGRAM
(SCALER PCB)
8
8
R3631
R3628
RX
H_INT
3
EN
4
GND
5
NC
NC
6
NC
NC
7
UC_SCL
8
UC_SDA
9
7
W969
6
NC
32
0
33
5.0
S
D
100P CH
37
AKM_PD#
36
35
AKM_ACKS
0
R3652
4.7K
R3654
4.7K
4.7K
R3649
4.7K
5
F
34
AKM_DIF0
P_SEL
NC
25
26
27
28
29
30
31
5.0 NC5.0 NC1.5 NC1.4 NC 5.0
0 NC3.4 NC
G
4.7K
38
R3632
DDVS
C3723
3.3
0.1
24
5.0
10K
0
RXT_RST#
C3647
23
5.0
NC
AUDIO_SEL
R3647
0
LEVEL SHIFT
Q3620
KTK5132E
100
40
17
MUTE_CTL
VIDEO_SEL
1.3
PROGRAM
HDMI MICON IC
0
IC3611
NC
NC
SST89E58RD2-40-C-TQJE(HD201)
5.0
VCC
5.0
21 NC
AKM_PD
AKM_ACKS 35
3.3
22 RXT0_RST
RX1_RST
RX2_RST 34
5.0
39
16
GND
NC
33
R3717
R3648
5.0
5.6K
42
41
R3718
14
43
CSCL
5.0
NC
5.0
NC
5.0
NC
0
44
W970
CSDA
RESET
NC
RXD
TXD
RX1_INT
CEC
NC
12
1
15
13
0
2
V_SYNC
H_INT
DDVS
4.6
3
H_SYNC
EA-/VPP
5.0
NC
4.6
4
NC 43
22
JG3605
CSDA
0
NC 44
NC
5.0
NC
1.24 4.9
6
5
ALE/PROG-
0
5.0
NC
7
13 AKM_SMUTE
NC
D 4.6
BUFFER
Q3606
S
KTK5132E
5.0
8
12 RX2_INT
18
1.2
NC
2.5
X1
19
0
9
X2
20
2.4
21
4.7K
18P CH
3.0
CSCL
5
C3643
3.3
G
R3639
4.7K
R3637
3.0 S
BUFFER
Q3605
KTK5132E
X3601
100CT01101
11.0592MHz
D 4.6
2.7
NC
P3.3/INT1-
8.2K
R3645
C3642
18P CH
RST1_RST
0.1 F
C3637
5.0
NC
UC_SDA
5.0
10
NC
4.7K
R3644
2.7
3.3 G
3.0
11
UC_SCL
VDD3
NC
4.9
GND
6
2
TX
UDZS3.3B
PSEN-
4.7K
R3643
F
0.1
0.1
F
C3640
C3639
SW
1
RX
TX
D3609
HDMI+5V
VCC
4.7K
4.7K
4.7K
R3619
10 V-S
C3641
2.2K
16V
4.6
R3641
4.6
D3613
CP3604
A2001WV2-9P
UDZS3.3B
C3638
SDA
0
0.1 F
GND
SCL
8
A2
WP
5.0
7
A1
VCC
6
0
FROM/TO INTERE_HDMI
A0
5
5.0
2
0
3
0
1
EEPROM IC
IC3608
BR24L32F-WE2
4
R3640
7
4.7K
W957
R3653
C3646
0.1
F
AKM_DIF0
HDMI_SW
SCK
AKM_SMUTE
4
4
SDO
WS
CP3602
A2001WV2-4P
B3606
4 HDMI_I2SSCK/MCKL
HDMI_I2SSDO
2
HDMI_I2SWS
1
GND
W1024
B3612
BLM18BD102SN1
RXT0_RST
3
3
W839
BLM18BD102SN1
2
RXT1_RST
3
2
PCBDS0
CEF156
1
H-35
A
B
C
1
NOTE:THE DC VOLTAGE AT EACH PART WAS MEASURED
WITH THE DIGITAL TESTER WHEN THE COLOR BROADCAST
WAS RECEIVED IN GOOD CONDITION AND PICTURE IS NORMAL.
NOTE: THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME
OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE
D
E
F
G
H
H-36
A
B
C
D
E
F
G
H
OPERATION/FILTER SCHEMATIOC DIAGRAM
8
8
(OPERATION PCB)
7
D3901
D3902
TO JACK
1
EYF-52BCY
EYF-52BCY
T8A H 250V
8A 125V
W860
R2201
R2202
5.6K 1/4W
2.2K 1/4W
R2203
1.2K 1/4W
R2206
R2204
820 1/4W
390 1/4W
CP3901
A3963WV2-3PD
2
CP3900
0.01 B
1
4
W856
INSERT C2204_1
D2203
W857
MTZJ4.7B-EIC
EVQ21505R
CH DOWN/UP
SW2206
EVQ21505R
EVQ21505R
CH UP/DOWN
SW2204
INPUT SELECT
SW2201
W858
6
5
1
GND
CD2203
CU23A002
PH3901
003P-2100
1
2
2
0.01 B
MTZJ4.7B-EIC
EVQ21505R
D2202
EVQ21505R
3
KEY B
PCBD00
CEE131
W859
TR6502
W5T29X7.5X19
INSERT C2209_1
POWER ON/OFF
SW2205
VOL DOWN/UP
SW2202
EVQ21505R
VOL UP/DOWN
SW2203
W855
KEY A
PH3900
003P-2100
A3963WV2-3PD
390 1/4W
F3900
FH3901
8A125V
D3900
R2205
5
FH3900
CP2203 (CP2200)
A2001WR2-3P
1
ENE471D-10A
6
DSS-272M
(FILTER PCB)
ENE271D-10A
7
CD3901
CUU33002
CD3900
CUU21001
4
PCB270
CEE133
3
3
2
2
8A 125V
CAUTION:FOR CONTINUED PROTECTION AGAINST FIRE HAZARD,
REPLACE ONLY WITH THE SAME TYPE FUSE 8A 125V (F3900)
NOTE: THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME
OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE
1
NOTE:THE DC VOLTAGE AT EACH PART WAS MEASURED
WITH THE DIGITAL TESTER WHEN THE COLOR BROADCAST
WAS RECEIVED IN GOOD CONDITION AND PICTURE IS NORMAL.
PIECES REPAREES PAR UN
ETANT
ATTENTION:LES
DANGEREUSES AN POINT DE VUE SECURITE
N’UTILISER QUE CELLS DECRITES
DANS LA NOMENCLATURE DES PIECES
UNE PROTECTION CONTINUE LES RISQUES D’INCEIE
ATTENTION:POUR
N’UTILISER QUE DES FUSIBLE DE MEME TYPE 8A 125V (F3900)
H-37
A
B
C
D
E
THESE PARTS MARKED BY
CAUTION:SINCE
CRITICAL FOR SAFETY,USE ONES
F
DESCRIBED IN PARTS LIST ONLY
G
H
ARE
1
H-38
A
B
C
D
E
F
G
H
SIDE JACK PCB SCHEMATIC DIAGRAM
8
8
(SIDE JACK PCB)
R4493
75
FRONT VIDEO JACK
J4207
AV-5A-66H
TO TUNER AV
FRONT_S_Y
8
FRONT_S_L
1
H
2
E
NC
3
WHITE
FRONT_S_C
7
1
6
FRONT AUDIO L JACK
J4208
AV-5A-68H
E
FRONT_V_IN
22uH
H
GND
5
L4200
1K
2
4
R6504
NC
FRONT_A_IN_L
3
GND
3
BLM18BB600SN1
L
NC
2
B4208
V
NC
CP4200 (CP2201)
A2001WV2-8P
1 FRONT_A_IN_R
7
YELLOW
7
C6543
0.001 B
6
6
E
RED
1
2
22uH
R
L4227
1K
NC
R6505
3
CD4201
CH010903
H
J4209
AV-5A-67H
C6542
0.001 B
R6509
B4209
75
BLM18BB600SN1
R6506
B4210
5
6
2
4
5
3
1
J4206
S4-25SZ
C
Y
560
5
R6508
BLM18BB600SN1
75
W894
W899
4
4
PCBD90
W862
CEF210
3
3
2
2
1
H-39
NOTE: THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME
OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE
A
NOTE:THE DC VOLTAGE AT EACH PART WAS MEASURED
WITH THE DIGITAL TESTER WHEN THE COLOR BROADCAST
WAS RECEIVED IN GOOD CONDITION AND PICTURE IS NORMAL.
B
C
PIECES REPAREES PAR UN
ETANT
ATTENTION:LES
DANGEREUSES AN POINT DE VUE SECURITE
THESE PARTS MARKED BY
CAUTION:SINCE
CRITICAL FOR SAFETY,USE ONES
N’UTILISER QUE CELLS DECRITES
DANS LA NOMENCLATURE DES PIECES
D
E
F
ARE
1
DESCRIBED IN PARTS LIST ONLY
G
H
H-40
WAVEFORMS
TUNER
ADC
2.0ms
20ns
1.0V
1
2.0V
20µs
1.0V
6
11
SOUND AMP/HEADPHON AMP
2.0ms
500mV
2
STEREO
2.0ms
2.0V
2.0ms
500mV
7
12
AV SWITCH2
2.0ms
500mV
3
100µs
2.0V
2.0ms
500mV
8
13
MICON
2.0ms
2.0V
4
100µs
50ns
500mV
2.0V
9
14
SCALER
2.0ms
2.0V
5
20µs
500mV
20µs
500mV
10
15
NOTE: The following waveforms were measured at the point of the corresponding
balloon number in the schematic diagram.
I-1
WAVEFORMS
20µs
500mV
1.0ms
500mV
16
21
26
20µs
1.0V
ADC
20µs
500mV
5µs
10µs
500mV
2.0V
17
27
22
ADC
20µs
5µs
200mV
2.0V
18
5µs
500mV
23
28
LVDS
20µs
200mV
10ms
100mV
19
24
5µs
500mV
29
JACK
20µs
200mV
20
INTERFACE_HDMI IC
1.0ms
1.0V
20µs
1.0V
25
30
NOTE: The following waveforms were measured at the point of the corresponding
balloon number in the schematic diagram.
I-2
WAVEFORMS
20µs
1.0V
31
20µs
1.0V
32
1.0ms
1.0V
43
1.0ms
1.0V
44
NOTE: The following waveforms were measured at the point of the corresponding
balloon number in the schematic diagram.
I-3
MECHANICAL EXPLODED VIEW
223
PCBD00
(FILTER PCB ASS'Y)
223 113 213
104A
223
104A
224 221
137
144
224
213
124
221
209
123
140
125
209
104B
214 214
208
143
124
224
124
120
221
139
122
209
123
104A
104
221
214
214
223
223
137
111
210
110
202
125
209
135
V801
202
202
102F
103C
214
111
102B
214
102D
218
102G
210
110
212
102G
102
202
203
203
145
147
203
226
202
147
V802
202
202
203
119 203
107C
205
202
202
202
214 202
202
202
119 203
202
214
214
202
105
103B
119 203
118
204
225
105C
103
202
214 202
202
107A
203
207
106A
106
229
PCBD90
(SIDE JACK PCB AS'Y)
116
132
203
103B
202
119
215
203
101H
101E
203
203
215
215
107
229
215
129
101H
101E 101O
215
215
215
215
203
203
219
101F
136
126
146
101G
219
101N
203
101I
222
203 101H
101I
101E
219
203
219
101F
101A
216
203
203
204
223
141
132
114
223
223
223
223
142
133
105A
138
206
PCBDA0
(REMOCON PCB ASS'Y)
223
PCBDS0
(SCALER PCB ASS'Y)
223
223
223
138
223
138
PCBD20
(AV PCB ASS'Y)
143 216
PCB270
216
(OPERATION PCB ASS'Y)
101K
129
203
101
203
148
223
223
138
223
138
203
216
101M
101D
101G
203
223
138
223
101C
222
101H 101O
101E 203 101O
101J
203
204
204
101L
222101O
203
130
105B
107B
215
101B
220
102A
218 214 112
202
106B
203
102H
208
103C
145
220
227
202
125
209
102E
208
103A
209
123
102C
214
214
134
217 202
220
220
102F
102F
108B
108A
220
102F
201
117
224
227227
220
212
228
102F
108
214
125
209
138
214
214
104A
211
121
209
123
223
220
220
131
115
216
130
203
203
203
203
127
203
146
128
NOTE: Speaker is not included in Front Cabinet Ass'y.
J-1
J-2
MECHANICAL EXPLODED VIEW
(PACKING DIAGRAM)
156
149
156
156
156
155
158
109, 159,
CD3820, TM101, TR3820
153
153
157
150
151
152
152
154
J-3
MECHANICAL REPLACEMENT PARTS LIST
Location No.
TSB P/N
Reference No.
Description
101
101A
101B
101C
101D
101E
101F
101G
101H
101I
101J
101K
101L
101M
101N
101O
75004001
75003994
72784168
72784169
72783966
72783968
72784208
75002702
72794733
72795699
72783967
72783965
72783969
75003998
72781222
72781215
7A701A778A
701WPJD346
702WPA1252
702WPA1253
713WPA0386
761WPA0431
800WF00065
800WQ00107
801WR00001
899EFBA002
7235490077
711WPA0254
774WPA0009
752WSAA136
800WQ0A092
800WQ00095
FRONT CABI ASS'Y
CABINET FRONT
COVER,SPEAKER (L)
COVER,SPEAKER (R)
GLASS,LED
HOLDER,SPEAKER
CUSHION
FELT SHEET 9*390*T1.0
DAMPER SPEAKER
WIRING-CLIP
BADGE,BRAND
PLATE,REMOCON
HOLDER CORD
SHIELD EARTH
FELT SHEET
FELT SHEET
102
102A
102B
102C
102D
102E
102F
102G
102H
72783970
72783975
72783971
72784187
72784188
72781991
72783974
72795625
72781311
7A7040012A
7G7610058A
704WPB0017
761WEB0010
761WEB0011
89982E42A0
800WRA0008
800WQ0A041
899000NK4N
STAND ASS'Y
ANGLE STAND ASS'Y
STAND
FRAME,BOTTOM-L
FRAME,BOTTOM-R
BAND
CUSHION,LEG
FELT SHEET
CABLE CLAMPS
103
103A
103B
103C
72783979
72783980
72783981
72784212
7A7020076A
702WSB0129
800WQ00115
800WQ0A129
BACK CABI ASS'Y
CABINET,BACK
FELT SHEET
FELT SHEET
104
104A
104B
72784203
72783992
72784194
7G7520032B
709WPA0043
762WSAA015
ANGLE PCB ASS'Y
HOLDER,CORD
ANGLE PCB
105
105A
105B
105C
75003957
75003951
75003945
72783989
7G761A029A
761WSBA005
723000D384
7230008140
PLATE JACK ASS'Y
PLATE JACK
SHEET JACK 1
SHEET,JACK-2
106
106A
106B
72783984
72783985
72783986
7A7010192A
711WPA0256
7230008098
PLATE,JACK-SIDE ASS'Y
PLATE,JACK-SIDE
SHEET,JACK(SIDE)
107
107A
107B
107C
72783991
72783992
72783993
72795680
7G752A007A
709WPA0043
762WSA0088
8995034000
SHIELD,MAIN-BOTTOM ASS'Y
HOLDER,CORD
SHIELD,MAIN-BOTTOM
CORD CLIP UL CO.
108
108A
108B
75003958
72783978
75003952
7G761A031A
702WPA1218
761WSBA006
COVER BACK ASS'Y
COVER,CONNECTOR
COVER BACK
109
75003970
J30A0121A
INSTRUCTION BOOK(E/F)
110
111
112
113
114
115
116
117
118
119
72784018
72784172
75003995
72784001
72784179
72784002
72784003
72784180
72784182
72784183
899ML02111
705WPA0020
722549A620
7260000353
752WSA0565
738WPB0077
752WSA0554
752WSA0593
753WEAA003
753WUA0082
CABLE,CLAMP
HANDLE BACK
SHEET RATING
SHEET EARTH MARK
SHIELD SCALER
BUTTON,FRAME
SHIELD,JACK-SIDE
SHIELD,PLATE
SHEET CU
SPRING,EARTH
K1-1
MECHANICAL REPLACEMENT PARTS LIST
Location No.
TSB P/N
Reference No.
Description
120
121
122
123
124
125
126
127
128
129
72784185
72784004
72784005
72784006
72784007
72784008
72784009
72784010
72784011
72784012
753WUA0084
761WEA0012
761WEA0013
761WEA0014
761WPA0427
761WPA0428
762WSA0085
762WSA0086
762WSA0087
800WFA0088
SPRING EARTH
FRAME,MAIN-L
FRAME,MAIN-R
HOLDER,PANEL
HOLDER,BUSH
HOLDER,CAP
SHIELD,MAIN-L
SHIELD,MAIN-R
SHIELD,MAIN-TOP
CUSHION
130
131
132
133
134
135
136
137
138
139
72784013
75003999
72784221
75003949
72784176
72795680
75003997
72795888
72795699
72784177
800WFA0089
753WEAA007
890MP2401G
752WSAA132
7250000606
8995034000
723549A069
800WFAA008
899EFBA002
7250000607
CUSHION
SHEET CU
TAPE 30X12
SHIELD JACK
SHEET CAUTION
CORD CLIP UL CO.
POP LABEL
CUSHION C
WIRING-CLIP
SHEET PE
140
141
142
143
144
145
146
147
148
149
72784220
75003961
72781305
72784223
72781306
72784016
72784017
72784014
72784015
75003996
890201FR50
8965TS0270
8965TS1015
8965TS1030
8965TS1060
8965TS2680
8965TS2730
8965TS2B70
8965TS2C15
723000D375
TAPE 100*50
CUSHION W6/H2/L70
CUSHION 65TS10-5(10*5*15)
CUSHION W10/H10/L30
CUSHION W10/H10/L60
CUSHION W6/H2/L680
CUSHION W6/H2/L730
CUSHION W6/H2/L1170
CUSHION W6/H2/L1215
SHEET BAR CODE
150
151
152
153
154
155
156
157
158
159
72784020
72784021
72784023
72784197
72784024
75004000
72784026
72784178
75003963
72794754
791WHA0117
791WHA0118
792WHA0650
792WHA0679
793WCA0019
793WCDD247
794WHAA003
7290000174
A30A01C975
JA4UD100
LAMI BAG
LIGHTRON SHEET
PACKAGE,BOTTOM
PACKAGE TOP
GIFT,BOX BOTTOM
GIFT BOX TOP
HANDLE
SHEET,PICTURE SHIFT
INSTRUCTION BOOK KIT
POLYBAG INSTRUCTION(RED CAUTION)
201
202
203
204
205
206
207
208
209
72784033
72784031
72798791
72784034
72798787
72781255
72798789
72784214
72784216
810763080S
8117540A6S
8110630A0U
810923080S
810923080U
8109I3080U
8109I30A0U
810273060S
810A140A6U
SCREW,TAP TITE(S) BRAZIER 3*8 BK
SCREW,TAPPING(B0) TRUSS
4*16 BK
SCREW TAP TITE(P) BRAZIER 3*10 CH
SCREW TAP TITE(B) BIND 3*8 BK
SCREW TAP TITE(B) BIND 3*8 CH
SCREW TAP TITE(B) WH7 3*8 CH
SCREW TAP TITE(B) WH7 3*10 CH
SCREW,PLANE-R M3*6 BK
SCREW WASHER(A) M4*16 CH
210
211
212
213
214
215
216
217
218
219
75003960
72784217
72784039
72784035
72784041
72784042
72798790
72784043
72784044
72781276
810B150A2S
810B140A0U
810B150B0S
810C14080U
810F23060S
8110230A4S
811063080U
8110630A0S
8110E3080S
8117140A2U
SCREW,SEMS(B) 5*12 BK
SCREW SEMS(B) 4*10 CH
SCREW,SEMS(B) 5*20 BK
SCREW WASHER C 4*8 CH TOOTHED
SEMS(F)-R BIND 3*6 BK
SCREW TAP TITE(P) BIND 3*14 BK
SCREW TAP TITE(P) BRAZIER 3*8 CH
SCREW TAP TITE(P) BRAZIER 3*10 BK
SCREW,TAP TITE(P) WH10 3*8 BK
SCREW,TAPPING(B0) PAN 4*12 CH
K1-2
MECHANICAL REPLACEMENT PARTS LIST
Location No.
220
221
222
223
224
225
226
227
228
229
TSB P/N
72781277
72798795
72781295
72784036
72784218
72784032
72784040
72784215
72781977
72781292
Reference No.
8117540A0U
8117540B0U
8162540A6U
810B13080U
8167150B0U
810213080S
810233080S
810A140A4U
814623080U
8159130A0S
Description
SCREW TAPPING(B0) TRUSS
4*10 CH
SCREW TAPPING(B0) TRUSS
4*20 CH
SCREW TAPPING (BO) WASHER 18
SCREW WASHER(B) M3*8 CH
SCREW WASHER(B) 5*20 CH
SCREW PAN M3*8 BK
SCREW,FLAT M3*8 BK
SCREW WASHER(A)
M4*14 CH
SCREW TAP TITE(B) BIND 3*5.7+4*2.3 CH
SCREW TAPPING(B) WASHER12 PAN 3*10 BLACK
K1-3
ELECTRICAL REPLACEMENT PARTS LIST
Location No.
TSB P/N
Reference No.
Description
CAPACITORS
C340
C342
C2204
C2209
C3801
C3802
C3803
C3823
C3825
C3826
72794410
72794410
75003486
75003486
72784045
72784045
72784045
72781395
72794410
72794410
E5EZF3102M
E5EZF3102M
CQG0B0414K
CQG0B0414K
E61FF2102D
E61FF2102D
E61FF2102D
E61FF4102D
E5EZF3102M
E5EZF3102M
CE
CE
CC
CC
CE
CE
CE
CE
CE
CE
1000 UF 25V
1000 UF 25V
0.01 UF 50V B
0.01 UF 50V B
1000 UF 16V
1000 UF 16V
1000 UF 16V
1000 UF 35V
1000 UF 25V
1000 UF 25V
D105
D109
D302
D303
D304
D305
D306
D802
D803
D805
D807
D808
D901
D2202
D2203
D2251
D2252
D2275
D3206
D3207
D3208
D3209
D3212
D3600
D3601
D3602
D3603
D3604
D3605
D3609
D3613
D3626
D3627
D3628
D3629
D3630
D3803
D3804
D3805
D3809
! D3900
! D3901
! D3902
D4202
D4203
D4205
D4206
D4207
D4208
D4209
D4210
D4211
D4212
D4301
D4302
72781371
72781371
72797300
72797300
72797300
72797300
72781371
72781375
72781375
72781375
72795897
72795897
72783214
72783367
72783367
72794467
72794491
72795897
72797300
72797300
72797300
72797300
72797300
72781372
72781361
72781375
72781361
72781372
72781372
72781374
72781374
72781361
72781361
72797300
72797300
72781375
72781352
72783759
72783759
72797300
72784073
72795544
72794484
72784074
72784074
72781369
72783414
72783414
72784074
72794491
72784074
72784074
72784074
72781375
72781375
DD7R20S300
DD7R20S300
D28R1QS040
D28R1QS040
D28R1QS040
D28R1QS040
DD7R20S300
DE7RB5R62B
DE7RB5R62B
DE7RB5R62B
DD7R0S3550
DD7R0S3550
D9WU05R62B
D9WU04R72B
D9WU04R72B
0021E9Q010
D1VT001330
DD7R0S3550
D28R1QS040
D28R1QS040
D28R1QS040
D28R1QS040
D28R1QS040
DD7R60L400
D77R1A1R10
DE7RB5R62B
D77R1A1R10
DD7R60L400
DD7R60L400
DE7RB3R32B
DE7RB3R32B
D77R1A1R10
D77R1A1R10
D28R1QS040
D28R1QS040
DE7RB5R62B
D23A0010J0
D4AT01H3E0
D4AT01H3E0
D28R1QS040
D6C047110A
D6E027110A
DOU002720M
DE7RB1202B
DE7RB1202B
D9WU06R82B
D9WU08R22B
D9WU08R22B
DE7RB1202B
D1VT001330
DE7RB1202B
DE7RB1202B
DE7RB1202B
DE7RB5R62B
DE7RB5R62B
DIODE,SCHOTTKY BARRIER
DIODE,SCHOTTKY BARRIER
DIODE
DIODE
DIODE
DIODE
DIODE,SCHOTTKY BARRIER
DIODE,ZENER
DIODE,ZENER
DIODE,ZENER
DIODE,SILICON
DIODE,SILICON
DIODE,ZENER
DIODE,ZENER
DIODE,ZENER
LED
DIODE,SILICON
DIODE,SILICON
DIODE
DIODE
DIODE
DIODE
DIODE
DIODE,SCHOTTKY
DIODE,VARISTA
DIODE,ZENER
DIODE,VARISTA
DIODE,SCHOTTKY
DIODE,SCHOTTKY
DIODE,ZENER
DIODE,ZENER
DIODE,VARISTA
DIODE,VARISTA
DIODE
DIODE
DIODE,ZENER
DIODE,SCHOTTKY
DIODE,RECTIFIER
DIODE,RECTIFIER
DIODE
DIODE,VARISTA
DIODE,VARISTA
DIODE,VARISTA
DIODE,ZENER
DIODE,ZENER
DIODE,ZENER
DIODE,ZENER
DIODE,ZENER
DIODE,ZENER
DIODE,SILICON
DIODE,ZENER
DIODE,ZENER
DIODE,ZENER
DIODE,ZENER
DIODE,ZENER
IC101
IC102
IC103
IC104
! IC301
IC801
IC904
IC2101
75004040
72795101
75004009
75004008
72781462
72784084
72781455
72781516
S30B01CM01
I9UF032290
S30B01CE02
S30B01CE01
I1MFPA2020
I56K07A720
I19FF4440G
IFSK0883C0
MEMORY DATA
IC
MEMORY DATA
MEMORY DATA
IC
IC
IC
IC
DIODES
RB520S-30-TE61
RB520S-30-TE61
EC31QS04-TE12L
EC31QS04-TE12L
EC31QS04-TE12L
EC31QS04-TE12L
RB520S-30-TE61
UDZS5.6B TE-17
UDZS5.6B TE-17
UDZS5.6B TE-17
1SS355 TE-17
1SS355 TE-17
MTZJ5.6B-EIC
MTZJ4.7B-EIC
MTZJ4.7B-EIC
LTL-1BEFJ-002A
1SS133T-77
1SS355 TE-17
EC31QS04-TE12L
EC31QS04-TE12L
EC31QS04-TE12L
EC31QS04-TE12L
EC31QS04-TE12L
RB160L-40-TE25
AVRL161A1R1NT
UDZS5.6B TE-17
AVRL161A1R1NT
RB160L-40-TE25
RB160L-40-TE25
UDZS3.3B TE-17
UDZS3.3B TE-17
AVRL161A1R1NT
AVRL161A1R1NT
EC31QS04-TE12L
EC31QS04-TE12L
UDZS5.6B TE-17
SBR100-10J-CBC11
1H3-E
1H3-E
EC31QS04-TE12L
ENE471D-10A
ENE271D-10A
DSS-272M-S00B
UDZS12B TE-177
UDZS12B TE-177
MTZJ6.8B-EIC
MTZJ8.2B-EIC
MTZJ8.2B-EIC
UDZS12B TE-177
1SS133T-77
UDZS12B TE-177
UDZS12B TE-177
UDZS12B TE-177
UDZS5.6B TE-17
UDZS5.6B TE-17
ICS
K2-1
OEC7164A
PST3229NR
AT24C256N-10SU-2.7
AT24C256N-10SU-2.7
TA2024-ASE
R8J66607A72FP
MSP4440G-QA-C13-100
MST9883C-LF-110
ELECTRICAL REPLACEMENT PARTS LIST
Location No.
TSB P/N
Reference No.
Description
ICS
IC2275
! IC3201
! IC3202
! IC3203
IC3601
IC3602
IC3605
IC3606
IC3608
IC3609
IC3611
IC3803
! IC3804
IC3805
IC3808
IC4201
IC4204
IC4304
IC4305
IC7202
IC7501
IC8103
IC8104
72797569
72781440
72783780
72783780
72783780
72781440
72784078
72796085
72784079
72796085
72784080
72781439
72781444
72797534
72784081
72794501
72797567
72795918
72795918
72784082
72784083
72794502
72797567
I0QF0580V0
I07F0C0WF0
I07F078200
I07F078200
I07F078200
I07F0C0WF0
IG1F090210
I57J0L02F0
I57J0L32F0
I57J0L02F0
ICMF0T89E0
I07F093000
I0GA9XF010
I03D979950
I07A078100
I01F05853B
I0QF025840
I0QF02534V
I0QF02534V
IF8F0385A0
IF8K010000
I0UF015010
I0QF025840
IC
IC
IC
IC
IC
IC
IC
IC
IC
IC
IC
IC
IC
IC
IC
IC
IC
IC
IC
IC
IC
IC
IC
NJM4580V(TE1)
BA00BC0WFP-E2
BD7820FP-E2
BD7820FP-E2
BD7820FP-E2
BA00BC0WFP-E2
SII9021CTU
BR24L02F-WE2
BR24L32F-WE2
BR24L02F-WE2
SST89E58RD2-40-C-TQJE
BD9300FV-E2
PQ070XF01SZH
LA7995M-TLM
BA7810T-V5
AN15853B-E1
NJM2584AM(TE1)
NJM2534V(TE2)
NJM2534V(TE2)
ICSV385AGLFT
DV1000-75
MM1501XNRE
NJM2584AM(TE1)
Q101
Q104
Q105
Q106
Q300
Q301
Q302
Q901
Q902
Q2101
Q2251
Q2252
Q2275
Q2276
Q2277
Q3205
Q3206
Q3210
Q3211
Q3603
Q3604
Q3605
Q3606
Q3607
Q3613
Q3614
Q3615
Q3616
Q3617
Q3618
Q3619
Q3620
Q3621
Q3801
Q3802
Q3804
Q3805
Q3806
Q3807
Q3808
Q4200
Q4201
Q4203
Q4205
Q4206
Q4207
Q4208
Q4209
Q4210
Q4211
Q4231
72794567
72783825
72798367
72783825
72794571
72794571
72794571
72794571
72794571
72794566
72784102
72794571
72794571
72783824
72794566
72798319
72795962
72794571
72794571
72783825
72783825
72783825
72783825
72783825
72794571
72794571
72783825
72783825
72783825
72783825
72794571
72783825
72794571
72798367
72795962
72798367
72795962
72794571
72783823
72781787
72794566
72794566
72794571
72794571
72794571
72794571
72783825
72794571
72783825
72794566
72798367
TNAAC05002
T2AA5132E0
TPAAC05002
T2AA5132E0
TCAA3875SY
TCAA3875SY
TCAA3875SY
TCAA3875SY
TCAA3875SY
TAAA1504SY
0001L00070
TCAA3875SY
TCAA3875SY
TAAA1544T0
TAAA1504SY
T77J011320
TNAAB05003
TCAA3875SY
TCAA3875SY
T2AA5132E0
T2AA5132E0
T2AA5132E0
T2AA5132E0
T2AA5132E0
TCAA3875SY
TCAA3875SY
T2AA5132E0
T2AA5132E0
T2AA5132E0
T2AA5132E0
TCAA3875SY
T2AA5132E0
TCAA3875SY
TPAAC05002
TNAAB05003
TPAAC05002
TNAAB05003
TCAA3875SY
TAAA1505SY
T0300J6500
TAAA1504SY
TAAA1504SY
TCAA3875SY
TCAA3875SY
TCAA3875SY
TCAA3875SY
T2AA5132E0
TCAA3875SY
T2AA5132E0
TAAA1504SY
TPAAC05002
COMPOUND TRANSISTOR
FET
COMPOUND TRANSISTOR
FET
TRANSISTOR,SILICON
TRANSISTOR,SILICON
TRANSISTOR,SILICON
TRANSISTOR,SILICON
TRANSISTOR,SILICON
TRANSISTOR,SILICON
PHOTO DIODE
TRANSISTOR,SILICON
TRANSISTOR,SILICON
TRANSISTOR,SILICON
TRANSISTOR,SILICON
TRANSISTOR,SILICON
COMPOUND TRANSISTOR
TRANSISTOR,SILICON
TRANSISTOR,SILICON
FET
FET
FET
FET
FET
TRANSISTOR,SILICON
TRANSISTOR,SILICON
FET
FET
FET
FET
TRANSISTOR,SILICON
FET
TRANSISTOR,SILICON
COMPOUND TRANSISTOR
COMPOUND TRANSISTOR
COMPOUND TRANSISTOR
COMPOUND TRANSISTOR
TRANSISTOR,SILICON
TRANSISTOR,SILICON
FET
TRANSISTOR,SILICON
TRANSISTOR,SILICON
TRANSISTOR,SILICON
TRANSISTOR,SILICON
TRANSISTOR,SILICON
TRANSISTOR,SILICON
FET
TRANSISTOR,SILICON
FET
TRANSISTOR,SILICON
COMPOUND TRANSISTOR
TRANSISTORS
K2-2
KRC103SRTK
KTK5132E-RTK/P
KRA103SRTK
KTK5132E-RTK/P
KTC3875S_Y_RTK
KTC3875S_Y_RTK
KTC3875S_Y_RTK
KTC3875S_Y_RTK
KTC3875S_Y_RTK
KTA1504S_Y_RTK
HPI6FGR4F2
KTC3875S_Y_RTK
KTC3875S_Y_RTK
KTA1544T-RTK/P
KTA1504S_Y_RTK
2SB1132T100(Q,R)
KRC102SRTK
KTC3875S_Y_RTK
KTC3875S_Y_RTK
KTK5132E-RTK/P
KTK5132E-RTK/P
KTK5132E-RTK/P
KTK5132E-RTK/P
KTK5132E-RTK/P
KTC3875S_Y_RTK
KTC3875S_Y_RTK
KTK5132E-RTK/P
KTK5132E-RTK/P
KTK5132E-RTK/P
KTK5132E-RTK/P
KTC3875S_Y_RTK
KTK5132E-RTK/P
KTC3875S_Y_RTK
KRA103SRTK
KRC102SRTK
KRA103SRTK
KRC102SRTK
KTC3875S_Y_RTK
KTA1505S-Y-RTK/P
2SJ650
KTA1504S_Y_RTK
KTA1504S_Y_RTK
KTC3875S_Y_RTK
KTC3875S_Y_RTK
KTC3875S_Y_RTK
KTC3875S_Y_RTK
KTK5132E-RTK/P
KTC3875S_Y_RTK
KTK5132E-RTK/P
KTA1504S_Y_RTK
KRA103SRTK
ELECTRICAL REPLACEMENT PARTS LIST
Location No.
TSB P/N
Reference No.
Description
TRANSISTORS
Q4233
Q4302
Q4305
Q4402
Q4403
Q8101
Q8102
Q8103
Q8105
Q8106
72795962
72794571
72794571
72798367
72795962
72794566
72794571
72794571
72794566
72794566
TNAAB05003
TCAA3875SY
TCAA3875SY
TPAAC05002
TNAAB05003
TAAA1504SY
TCAA3875SY
TCAA3875SY
TAAA1504SY
TAAA1504SY
COMPOUND TRANSISTOR
TRANSISTOR,SILICON
TRANSISTOR,SILICON
COMPOUND TRANSISTOR
COMPOUND TRANSISTOR
TRANSISTOR,SILICON
TRANSISTOR,SILICON
TRANSISTOR,SILICON
TRANSISTOR,SILICON
TRANSISTOR,SILICON
L300
L301
L302
L303
L901
L903
L904
L2101
L2102
L2103
L2106
L2107
L2275
L3601
L3602
L3603
L3604
L3605
L3606
L3607
L3608
L3623
L3801
L3802
L3803
L3804
L3805
L3808
L3809
L3810
L4200
L4202
L4203
L4204
L4206
L4207
L4211
L4212
L4213
L4214
L4215
L4216
L4217
L4218
L4219
L4220
L4221
L4227
L4301
L4306
L4403
L5800
L5801
L7201
L7202
L7203
L7502
L8102
L8104
L8105
72798924
72798924
72798924
72798924
72795062
72795062
72795062
72798914
72798914
72798916
72798912
72798914
72796089
72798955
72798955
72798955
72798955
72798955
72798955
72798955
72798955
72784092
72796513
72796513
72796513
72796513
72798897
72798924
72798897
72796087
72796402
72796089
72796089
72794536
72796089
72796089
72794540
72796571
72796571
72796571
72796571
72796571
72796571
72796571
72796571
72796571
72796571
72796402
72798916
72798914
72795062
72794526
72796571
72798916
72798916
72798916
72798916
72798916
72798916
72798914
021W0G100M
021W0G100M
021W0G100M
021W0G100M
02167F100J
02167F100J
02167F100J
0216S8220K
0216S8220K
0216S8470K
0216S8150K
0216S8220K
02167F470J
02D6000068
02D6000068
02D6000068
02D6000068
02D6000068
02D6000068
02D6000068
02D6000068
0216SD220J
02167E220K
02167E220K
02167E220K
02167E220K
0214646R8M
021W0G100M
0214646R8M
02167E100K
021LA6220K
02167F470J
02167F470J
021LA6330J
02167F470J
02167F470J
02167F101J
021LA6220J
021LA6220J
021LA6220J
021LA6220J
021LA6220J
021LA6220J
021LA6220J
021LA6220J
021LA6220J
021LA6220J
021LA6220K
0216S8470K
0216S8220K
02167F100J
02167F220J
021LA6220J
0216S8470K
0216S8470K
0216S8470K
0216S8470K
0216S8470K
0216S8470K
0216S8220K
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL,CHOKE
COIL,CHOKE
COIL,CHOKE
COIL,CHOKE
COIL,CHOKE
COIL,CHOKE
COIL,CHOKE
COIL,CHOKE
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
J2275
J3601
J4201
72796730
72784085
72784086
060J121014
060J131019
060K411049
JACK,RCA,3.5
HEADPHONE JACK
RCA JACK
KRC102SRTK
KTC3875S_Y_RTK
KTC3875S_Y_RTK
KRA103SRTK
KRC102SRTK
KTA1504S_Y_RTK
KTC3875S_Y_RTK
KTC3875S_Y_RTK
KTA1504S_Y_RTK
KTA1504S_Y_RTK
COILS &TRANSFORMERS
10 UH
10 UH
10 UH
10 UH
10 UH
10 UH
10 UH
22 UH
22 UH
47 UH
15 UH
22 UH
47 UH
ACM2012D-900-2P-T00
ACM2012D-900-2P-T00
ACM2012D-900-2P-T00
ACM2012D-900-2P-T00
ACM2012D-900-2P-T00
ACM2012D-900-2P-T00
ACM2012D-900-2P-T00
ACM2012D-900-2P-T00
22 UH
22 UH
22 UH
22 UH
22 UH
6.8 UH
10 UH
6.8 UH
10 UH
22 UH
47 UH
47 UH
33 UH
47 UH
47 UH
100 UH
22 UH
22 UH
22 UH
22 UH
22 UH
22 UH
22 UH
22 UH
22 UH
22 UH
22 UH
47 UH
22 UH
10 UH
22 UH
22 UH
47 UH
47 UH
47 UH
47 UH
47 UH
47 UH
22 UH
JACKS
K2-3
MSJ-035-12A_PC
MSJ-2000B_AG(O87)
AV3-13P2-11S1
ELECTRICAL REPLACEMENT PARTS LIST
Location No.
TSB P/N
Reference No.
Description
JACKS
J4204
J4205
J4206
J4207
J4208
J4209
J4211
J4301
75003937
72784089
72783793
72783794
72783795
72783796
75003936
72784091
060K471011
063E000082
063E700012
060K421056
060K421058
060K421057
060K441006
060J431025
RCA JACK
JACK,PLATE
JACK
RCA JACK
RCA JACK
RCA JACK
RCA JACK
RCA JACK
SW2201
SW2202
SW2203
SW2204
SW2205
SW2206
72794688
72794688
72794688
72794688
72794688
72794688
0504101T34
0504101T34
0504101T34
0504101T34
0504101T34
0504101T34
SWITCH,TACT
SWITCH,TACT
SWITCH,TACT
SWITCH,TACT
SWITCH,TACT
SWITCH,TACT
PCB270
PCBD00
PCBD20
PCBD90
PCBDA0
PCBDS0
75004002
75004003
75004004
75004005
75004006
75004007
A30B01C270
A30B01CD00
A30B01CD20
A30B01CD90
A30B01CDA0
A30B01CDS0
OPERATION PCB ASS'Y
FILTER PCB ASS'Y
AV PCB ASS'Y
SIDE JACK PCB ASS'Y
REMOCON PCB ASS'Y
SCALER PCB ASS'Y
B801
B802
B803
B804
B805
B806
B904
B906
B2101
B2271
B3201
B3202
B3203
B3205
B3206
B3207
B3601
B3602
B3603
B3604
B3605
B3606
B3612
B3613
B3621
B3622
B4204
B4205
B4206
B4208
B4209
B4210
B4211
B4214
B4215
B4216
B4217
B4218
B4219
B4220
B4221
B4222
B4303
B4304
B4305
B4307
B4308
B5801
B5802
B7202
B7501
B7502
72798930
72798930
72798931
72798931
72798930
72798931
72798929
72798929
72798931
72798931
72798930
72798930
72798930
72798930
72798930
72798930
72796605
72796605
72796605
72796605
72798931
72798929
72798929
72796605
72795787
72795787
72798931
72798931
72798931
72798931
72798931
72798931
72798931
72798931
72798931
72798931
72798931
72798931
72798931
72798931
72798931
72798931
72798931
72798931
72798931
72795787
72795787
72798930
72798930
72798931
72798931
72798930
024AC5181J
024AC5181J
024AC5600E
024AC5600E
024AC5181J
024AC5600E
024AC5102F
024AC5102F
024AC5600E
024AC5600E
024AC5181J
024AC5181J
024AC5181J
024AC5181J
024AC5181J
024AC5181J
024HC36001
024HC36001
024HC36001
024HC36001
024AC5600E
024AC5102F
024AC5102F
024HC36001
0246C51024
0246C51024
024AC5600E
024AC5600E
024AC5600E
024AC5600E
024AC5600E
024AC5600E
024AC5600E
024AC5600E
024AC5600E
024AC5600E
024AC5600E
024AC5600E
024AC5600E
024AC5600E
024AC5600E
024AC5600E
024AC5600E
024AC5600E
024AC5600E
0246C51024
0246C51024
024AC5181J
024AC5181J
024AC5600E
024AC5600E
024AC5181J
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
AV4-57A03-01H
SAV-12CP-01Z5
S4-25SZ
AV-5A-66H
AV-5A-68H
AV-5A-67H
AV6-53-13H
MSD-242VA1-03_NI_FE_LF
SWITCHES
EVQ21505R
EVQ21505R
EVQ21505R
EVQ21505R
EVQ21505R
EVQ21505R
P.C.BOARD ASSEMBLIES
CEE133A
CEE131A
CMF091A
CEF210A
CEF211A
CEF156A
MISCELLANEOUS
K2-4
BLM18PG181SN1D
BLM18PG181SN1D
BLM18BB600SN1D
BLM18BB600SN1D
BLM18PG181SN1D
BLM18BB600SN1D
BLM18BD102SN1D
BLM18BD102SN1D
BLM18BB600SN1D
BLM18BB600SN1D
BLM18PG181SN1D
BLM18PG181SN1D
BLM18PG181SN1D
BLM18PG181SN1D
BLM18PG181SN1D
BLM18PG181SN1D
HCB2012K-600T25
HCB2012K-600T25
HCB2012K-600T25
HCB2012K-600T25
BLM18BB600SN1D
BLM18BD102SN1D
BLM18BD102SN1D
HCB2012K-600T25
MMZ1608R102CT
MMZ1608R102CT
BLM18BB600SN1D
BLM18BB600SN1D
BLM18BB600SN1D
BLM18BB600SN1D
BLM18BB600SN1D
BLM18BB600SN1D
BLM18BB600SN1D
BLM18BB600SN1D
BLM18BB600SN1D
BLM18BB600SN1D
BLM18BB600SN1D
BLM18BB600SN1D
BLM18BB600SN1D
BLM18BB600SN1D
BLM18BB600SN1D
BLM18BB600SN1D
BLM18BB600SN1D
BLM18BB600SN1D
BLM18BB600SN1D
MMZ1608R102CT
MMZ1608R102CT
BLM18PG181SN1D
BLM18PG181SN1D
BLM18BB600SN1D
BLM18BB600SN1D
BLM18PG181SN1D
ELECTRICAL REPLACEMENT PARTS LIST
Location No.
!
!
!
!
!
BT001
BT002
CD301
CD303
CD801
CD802
CD803
CD804
CD901
CP101
CP102
CP103
CP301
CP303
CP802
CP803
CP901
CD2203
CD3801
CD3802
CD3803
CD3804
CD3807
CD3820
CD3831
CD3900
CD3901
CD4200
CD4201
CD4202
CD4203
CD4204
CD7206
CP2200
CP2203
CP2251
CP3201
CP3601
CP3602
CP3603
CP3604
CP3801
CP3802
CP3803
CP3804
CP3807
CP3900
CP3901
CP4200
CP4201
CP4202
CP4203
CP4204
CP4302
CP7202
ELD002
F3900
FH3900
FH3901
NR801
NR802
NR803
NR804
NR805
NR806
NR807
NR2101
NR2102
NR2103
NR2104
NR2105
NR2106
NR3601
NR3602
NR3603
TSB P/N
72783174
72783174
72784048
72784049
72784062
72784062
72784164
72784158
72784063
72796798
72796806
72796801
72784066
72796792
72799028
72799027
72796796
75003938
72784050
72784051
72784052
72784053
72784054
75003940
72784056
72784057
72784058
72784059
72784158
72784060
72799271
72799273
72784061
72796794
72796795
72799047
72796807
72799030
72796796
72799030
72796804
72784067
72784068
72784069
72784070
72796807
72796817
72796817
72796803
72796803
72796800
72799027
72799028
72799010
72784072
72797070
72784075
72794496
72794496
72799237
72799240
72799240
72799240
72799240
72799240
72799240
72797034
72797034
72797034
72797034
72797034
72797034
72799237
72799237
72799237
Reference No.
141U004016
141U004016
06CU13A301
06CU12A601
06CH011208
06CH011208
122Q312102
06CH010903
06CU247001
069S250629
069S2A0629
069S270629
069S130419
069S120419
069EVU3030
069EVT3030
069S240629
06CU23A002
06CU643701
06CU622201
06CU6C2901
06CU672301
06CU2B3901
120T024504
06CU012202
06CUU21001
06CUU33002
06CU28A005
06CH010903
06CU267901
122H0T0801
122H0U0802
06CUZV6301
069S230629
069S230639
069S260639
069S2B0629
069HYJ3010
069S240629
069HYJ3010
069S290629
069S140019
069S120019
069S1C0019
069S170019
069S2B0629
069S320419
069S320419
069S280629
069S280629
069S260629
069EVT3030
069EVU3030
0694S15017
069HTR001A
124120301A
081PC08005
06710T0009
06710T0009
110P4000M4
110P4470M4
110P4470M4
110P4470M4
110P4470M4
110P4470M4
110P4470M4
110P4101M4
110P4101M4
110P4101M4
110P4101M4
110P4101M4
110P4101M4
110P4000M4
110P4000M4
110P4000M4
Description
MISCELLANEOUS
BATTERY,MANGAN
BATTERY,MANGAN
CORD,CONNECTOR
CORD,CONNECTOR
CORD,CONNECTOR
CORD,CONNECTOR
CORD,JUMPER
CORD,CONNECTOR
CORD,CONNECTOR
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
CORD,CONNECTOR
CORD,CONNECTOR
CORD,CONNECTOR
CORD,CONNECTOR
CORD,CONNECTOR
CORD,CONNECTOR
CORD,AC
CORD,CONNECTOR
CORD,CONNECTOR
CORD,CONNECTOR
CORD,CONNECTOR
CORD,CONNECTOR
CORD,CONNECTOR
CORD,JUMPER
CORD,JUMPER
CORD,CONNECTOR
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
EYE LET
FUSE
HOLDER,FUSE
HOLDER,FUSE
R,NETWORK
R,NETWORK
R,NETWORK
R,NETWORK
R,NETWORK
R,NETWORK
R,NETWORK
R,NETWORK
R,NETWORK
R,NETWORK
R,NETWORK
R,NETWORK
R,NETWORK
R,NETWORK
R,NETWORK
R,NETWORK
K2-5
MNAAA(R03)
MNAAA(R03)
CU13A301
CU12A601
CH011208
CH011208
TD-OR0210Z
CH010903
CU247001
A2001WV2-5P
A2001WV2-10P
A2001WV2-7P
A2502WV2-3P
A2502WV2-2P
00_6232_030_006_800+
00_6232_029_006_800+
A2001WV2-4P
CU23A002
CU643701
CU622201
CU6C2901
CU672301
CU2B3901
0T024504
CU012202
CUU21001
CUU33002
CU28A005
CH010903
CU267901
2H0T0801
2H0U0802
CUZV6301
A2001WV2-3P
A2001WR2-3P
A2001WR2-6P
A2001WV2-11P
DC1R019JDA
A2001WV2-4P
DC1R019JDA
A2001WV2-9P
A2501WV2-4P
A2501WV2-2P
A2501WV2-12P
A2501WV2-7P
A2001WV2-11P
A3963WV2-3PD
A3963WV2-3PD
A2001WV2-8P
A2001WV2-8P
A2001WV2-6P
00_6232_029_006_800+
00_6232_030_006_800+
1-1734344-1
FI-TWE31PB-VF
XRY20X30BD
51MS080L
EYF-52BCY
EYF-52BCY
4D03WGJ0000T5E
4D03WGJ0470T5E
4D03WGJ0470T5E
4D03WGJ0470T5E
4D03WGJ0470T5E
4D03WGJ0470T5E
4D03WGJ0470T5E
4D03WGJ0101T5E
4D03WGJ0101T5E
4D03WGJ0101T5E
4D03WGJ0101T5E
4D03WGJ0101T5E
4D03WGJ0101T5E
4D03WGJ0000T5E
4D03WGJ0000T5E
4D03WGJ0000T5E
ELECTRICAL REPLACEMENT PARTS LIST
Location No.
!
!
!
!
!
NR3604
NR3605
NR3606
NR7203
NR7204
NR7501
NR7502
NR7503
NR7504
NR7505
NR7506
OS2251
PH3900
PH3901
SP301
SP302
SP303
SP304
TM101
TR301
TR302
TR3805
TR3806
TR4201
TR4202
TR4203
TR4204
TR4205
TR4206
TR6502
TU5800
V801
V802
X101
X801
X901
X3601
X3602
X7501
TSB P/N
72799237
72799237
72799237
72799238
72799238
72799240
72799240
72799240
72799240
72799240
72799240
72784093
72796825
72796825
72784103
72784103
72784104
72784104
75003939
72796088
72796088
72784107
72784106
72796088
72796088
72784106
72796088
72784107
72784106
72796088
75003831
72784108
72784109
72799226
72799227
72797001
72799220
72783835
72784110
Reference No.
110P4000M4
110P4000M4
110P4000M4
110P4220M4
110P4220M4
110P4470M4
110P4470M4
110P4470M4
110P4470M4
110P4470M4
110P4470M4
077A033001
069W01001A
069W01001A
0701016002
0701016002
0701026001
0701026001
076D0KK030
02AHB9A972
02AHB9A972
02A6C0A3Y1
02A6B3A3T1
02AHB9A972
02AHB9A972
02A6B3A3T1
02AHB9A972
02A6C0A3Y1
02A6B3A3T1
02AHB9A972
0162300048
09HD205001
09JE250001
100WT01611
100YT05401
100CT01803
100CT01101
100DT02801
100DT02006
Description
MISCELLANEOUS
R,NETWORK
R,NETWORK
R,NETWORK
R,NETWORK
R,NETWORK
R,NETWORK
R,NETWORK
R,NETWORK
R,NETWORK
R,NETWORK
R,NETWORK
REMOTE RECEIVER
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
SPEAKER
SPEAKER
SPEAKER
SPEAKER
TRANSMITTER
CORE,FERRITE
CORE,FERRITE
CORE,FERRITE
CORE,FERRITE
CORE,FERRITE
CORE,FERRITE
CORE,FERRITE
CORE,FERRITE
CORE,FERRITE
CORE,FERRITE
CORE,FERRITE
RF UNIT
PDP
PDP FILTER
CRYSTAL
CRYSTAL
CRYSTAL
CRYSTAL
CRYSTAL
CRYSTAL
RESISTOR
RC................... CARBON RESISTOR
CAPACITORS
CC................... CERAMIC CAPACITOR
CE................... ALUMI ELECTROLYTIC CAPACITOR
CP................... POLYESTER CAPACITOR
CPP................. POLYPROPYLENE CAPACITOR
CPL................. PLASTIC CAPACITOR
CMP................ METAL POLYESTER CAPACITOR
CMPL.............. METAL PLASTIC CAPACITOR
CMPP.............. METAL POLYPROPYLENE CAPACITOR
K2-6
4D03WGJ0000T5E
4D03WGJ0000T5E
4D03WGJ0000T5E
4D03WGJ0220T5E
4D03WGJ0220T5E
4D03WGJ0470T5E
4D03WGJ0470T5E
4D03WGJ0470T5E
4D03WGJ0470T5E
4D03WGJ0470T5E
4D03WGJ0470T5E
ROM-V338TAO
003P-2100
003P-2100
EAS12D175B
EAS12D175B
EAS5PH134C
EAS5PH134C
000-103000440
W5T29X7.5X19
W5T29X7.5X19
ZCAT3035-1330
ZCAT2436-1330A
W5T29X7.5X19
W5T29X7.5X19
ZCAT2436-1330A
W5T29X7.5X19
ZCAT3035-1330
ZCAT2436-1330A
W5T29X7.5X19
115-V-LA35ARH
PDP50X3####
FG510NAA-05
HC-49/U-S
FCX-03
HC-49/U-S
HC-49/U-S
SMD-49
DSO751SV
TOSHIBA CORPORATION
1-1, SHIBAURA 1-CHOME, MINATO-KU, TOKYO 105-8001, JAPAN