Download Parts Manual Fairway 250

24866G (rev.0)
Parts Manual
Fairway 250
Series: DH - Engine type: Kubota V1305
Product code: JGZZ010
WARNING: If incorrectly used this machine can cause severe injury.
Those who use and maintain this machine should be trained in its proper
use, warned of its dangers and should read the entire manual before
attempting to set up, operate, adjust or service the machine.
RJL 100 August 2010
©
2010, Ransomes Jacobsen Limited. All Rights Reserved
JACOBSEN FAIRWAY 250 SERIES: DH
DESCRIPTION
PAGE
PRODUCT IDENTIFICATION............................................................................................................. 2
SPARES STOCKING GUIDE ............................................................................................................. 2
SERVICE PARTS ............................................................................................................................... 3
HOW TO USE THE PARTS MANUAL................................................................................................ 4
GUIDELINES FOR THE DISPOSAL OF SCRAP PRODUCTS.......................................................... 5
FRAME AND REAR AXLE.................................................................................................................. 6
ENGINE MOUNTING......................................................................................................................... 10
ENGINE/HYDRAULIC TRANSMISSION DRIVE ............................................................................... 12
ENGINE PARTS ................................................................................................................................ 14
SERVO PUMP & THROTTLE CONTROLS....................................................................................... 16
FILTER MOUNTING .......................................................................................................................... 18
STEERING WHEEL & PEDAL MOUNTING ...................................................................................... 20
FRONT LIFT ARM MOUNTING......................................................................................................... 26
REAR LIFT ARM MOUNTING ........................................................................................................... 30
DRIVE WHEELS & BRAKES............................................................................................................. 34
HYDRAULIC RESERVOIR & FUEL TANK........................................................................................ 36
RADIATOR & OIL COOLER MOUNTING ......................................................................................... 40
BONNET HINGE ARRANGEMENT / REAR BUMPER ..................................................................... 42
SEAT MOUNTING ............................................................................................................................. 44
SEAT GRAMMER MSG 85 SEAT (4137966) - SUSPENSION ......................................................... 46
SEAT GRAMMER MSG 85 SEAT (4137966) -SEAT TOP................................................................ 48
SEAT GRAMMER (S 85 / 90R) ......................................................................................................... 50
SEAT SUSPENSION GRAMMER DS85H......................................................................................... 54
ELECTRICS - INSTRUMENT PANEL ............................................................................................... 58
ELECTRICS - VARIOUS COMPONENTS......................................................................................... 60
HYDRAULIC VALVE MOUNTING ..................................................................................................... 62
HYDRAULIC TRACTION CIRCUIT ................................................................................................... 66
HYDRAULIC CUTTINGS / STEER / LIFT CIRCUIT.......................................................................... 70
VALVE 4 WHEEL DRIVE................................................................................................................... 76
SERVO TRANSMISSION PUMP - SAUER SUNDSTRAND ............................................................. 78
TANDEM PUMP (ULTRA) ................................................................................................................. 80
CUTTING CYLINDER CONTROL VALVE (FWD / N / REV) ............................................................ 82
HYDRAULIC STEER GEAR .............................................................................................................. 84
LIFT VALVE ....................................................................................................................................... 86
REEL DRIVE VALVE ......................................................................................................................... 90
VALVE, REEL SPEED....................................................................................................................... 92
HYDRAULIC TRACTION MOTOR FRONT ....................................................................................... 94
HYDRAULIC TRACTION MOTOR REAR ......................................................................................... 96
DECALS............................................................................................................................................. 98
Parts - 1
JACOBSEN FAIRWAY 250 SERIES: DH
INTRODUCTION
PRODUCT IDENTIFICATION ______________________________________________________________
A
B
C
D
E
Machine Name
Serial Number
Year of Manufacture
Machine Weight
Engine Power
SPARES STOCKING GUIDE
To keep your equipment fully operational and productive, Ransomes suggests you maintain a
stock of the more commonly used maintenance items. We have included part numbers for
the additional support materials and training aids.
SERVICE SUPPORT MATERIAL
Part No.
Description
Part No.
Description
97898-0269-0
Engine Parts Manual
24543G
Safety and Operators Manual
16622-8916-2
Engine Operators Manual
24544G
Safety and Operators Manual
97897-0164-3
Engine Service Manual
Parts- 2
-
Machine Service Manual
JACOBSEN FAIRWAY 250 SERIES: DH
SERVICE PARTS
Part No.
Description
Part No.
Description
16282-3211-4
Engine Oil Filter
W178025
Hydraulic Filter (Suction)
15221-4308-0
Engine Fuel Filter
68371-5121-0
Electric Fuel Pump
2198147-01
Air Cleaner Element
13351-4301-1
In-line Fuel Filter
16616-6001-1
Stop Soleniod
Parts- 3
JACOBSEN FAIRWAY 250 SERIES: DH
HOW TO USE THE PARTS MANUAL
ITEM NUMBER
Each part which is identified in the illustrations has an item number. Parts which do not have an item
number may not be readily identified in the illustration but are usually closely associated with the
immediately adjacent part.
ASSEMBLIES
A complete assembly, e.g. a wheel motor or hydraulic motor or roll assembly, is listed as a complete
item with subsequent individual components listed separately.
The assembly is listed under it’s part number with component parts being listed offset to the right, e.g:ITEM
4295
4296
4298
4300
4301
4301.1
4301.2
4301.3
4301.4
4301.5
4301.6
4301.7
4301.8
PART NO.
MBG2504
MBG3848
450865
450378
Wl001
008162130
008170390
008161830
008169140
008169150
002993010
008161990
008170780
DESCRIPTION
Bracket
Latch
Screw, M8 X 20, Sckt Csk Hd
Nut, M8 Nyloc
Set Of Wheels
• Wheel & Hub Assy
• • Tyre
• • Rim
• • Hub Assy.
• • Cap
• • Lubricator
• Wheel & Tyre
• • Tyre
QTY
1
2
2
2
1
1
1
1
1
1
1
2
2
REMARKS
(Rear)
(Front)
It may not be possible to illustrate every item. With certain items purchased from outside suppliers
some component parts may not be available from Ransomes and may need to be specially ordered
from the supplier.
QUANTITIES
Quantities shown are for one assembly or sub-assembly.
USING THE PARTS LIST
Determine the function and application of the part required. Turn to the main index page and select the
appropriate section. Locate the part on the illustration and parts list and read off the quantity from the
appropriate MODEL column.
NUMERICAL INDEX
This is a summary of all part numbers used in the manual arranged in numerical sequence and showing the page and item number under which the parts appear.
ORDERING OF SPARE PARTS
When ordering replacement parts, it is most important to quote the SERIAL NUMBER of the machine,
PART NUMBER, DESCRIPTION and QUANTITY required.
Any arbitrary modifications carried out on this machine may relieve the manufacturer of liability for any
resulting damage or injury.
ABBREVIATIONS
N/A Not Available
ARAs Required
Parts- 4
JACOBSEN FAIRWAY 250 SERIES: DH
GUIDELINES FOR THE DISPOSAL OF SCRAP PRODUCTS
DURING SERVICE LIFE
Used oil, oil filters and engine coolant are hazardous materials and should be handled in a safe and
environmentally responsible way.
In the event of a fluid leak, contain the spill to prevent it entering the ground or drainage system. Local legislation
will dictate how such spills are to treated.
Following the maintenance procedures laid out in this manual will ensure that the impact the machine has on the
local environment is controlled.
When it has been identified that a turf care product has no further functional value and requires disposal, the
following actions should be taken.
END OF SERVICE LIFE
These guidelines should be used in conjunction with applicable Health, Safety and Environmental legislation and
use of approved local facilities for waste disposal and recycling.
•
•
•
•
•
•
•
•
Position the machine in a suitable location for any necessary lifting equipment to be used.
Use appropriate tools and Personal Protective Equipment (PPE) and take guidance from the technical
manuals applicable to the machine.
Remove and store appropriately:
1. Batteries
2. Fuel residue
3. Engine coolant
4. Oils
Disassemble the structure of the machine referring to the technical manuals where appropriate. Special
attention should be made for dealing with ‘stored energy’ within pressurised elements of the machine or
tensioned springs.
Any items that still have a useful service life as second hand components or can be re-serviced should
be separated and returned to the relevant centre.
Other worn out items should be separated into material groups for recycling and disposal consistent
with available facilities. More common separation types are as follows:
• Steel
• Non ferrous metals
• Aluminium
• Brass
• Copper
•Plastics
•Identifiable
• Recyclable
• Non recyclable
• Not identified
• Rubber
• Electrical & Electronic Components
Items that cannot be separated economically into different material groups should be added to the
‘General waste’ area.
Do not incinerate waste.
Finally update machinery records to indicate that the machine has been taken out of service and scrapped.
Provide this serial number to Ranmsomes Jacobsen Warranty department to close off relevant records.
Parts- 5
JACOBSEN FAIRWAY 250 SERIES: DH
FRAME AND REAR AXLE
73
74
75
Parts- 6
JACOBSEN FAIRWAY 250 SERIES: DH
ITEM
1-1
1-3
1-4
1-5
1-6
1-7
1-9
1-10
1-11
1-12
1-13
1-14
1-15
1-17
1-18
1-19
1-20
1-21
1-23
1-24
1-25
1-26
*
1-27
1-28
1-29
1-30
1-32
1-33
1-34
1-35
1-37
1-38
1-39
1-41
1-44
*
*
*
1-45
1-46
1-48
PART NO.
450380
2206030.07
2206013G.07
450191
001393820
842000044
450392
450241
62464-4A
W108003
450213
450412
64163-17
MBF2384
2721223
173042
451030667
2203049
001399024
008145490
800490
198040
198040-01
001399032
H083081
008162460
008170780
008162480
001341110
008145418
450334
MBG2163.07
64025-16
001009740
MBF1270A
450328
450372
MBG0969A.07
450971
450968
456800237
MBF1355
450056
450379
DESCRIPTION
LOCKNUT NYLOC M12-1.75
WLDMT REAR AXLE PIVOT
REAR AXLE ASSY
BOLT M 8 - 1.25X20
NUT HEX 1-1/4-12 NYLOC
1/4" STR GREASE NIPPLE
WASHER, M12
BOLT M12-1.75X30
WASHER, THRUST
BUSHING
BOLT-M10-1.5X20
LOCKWASHER M10
WASHER 25/64 x 2 x 11GA
WLDMT-REAR FRAME
THRUST BEARING
SPACER-SPINDLE
BOLT HEX 1/2-20 X 2.5"
BUSHING-STEERING CYL
NUT, 7/16-20 NYLOC
TRACK ROD END
NUT M14 - I.5
CYLINDER, STEERING
• SEAL KIT
1/2-20 HEX LOCKNUT
DISK SPRING (31.5x16.3x1)
ASSY - WHEEL 2OX 10X8
• TYRE 2OXIOX8
• RIM 8" 4 BOLT
WHEEL NUT 1/2 - 20
ROD END
NUT M16 THIN
TIE ROD
NUT 5/8 - 18 RH
BOLT-HEX M16 x 70 (10.9)
SPACER
M16 NYLOC
M10 NUTSERT
WHEEL HUB (WEIGHT)
SET SCREW M8 x 20
SET SCREW M8 x 10
STUD-1/2-20 x 1-1/2
NUT 1-20 UNSLOTTED TRW
BOLT-M12-1.75X80
NUT-HEX M12-1.75
* Not Illustrated
QTY.
14
1
1
4
1
3
12
14
4
6
2
2
2
1
2
2
1
1
1
1
1
1
1
1
AR
2
AR
AR
8
2
2
1
1
2
2
2
4
2
2
2
8
2
8
8
REMARKS
Torque 80Nm
Torque 270Nm
Parts- 7
JACOBSEN FAIRWAY 250 SERIES: DH
FRAME AND REAR AXLE
73
74
75
Parts- 8
JACOBSEN FAIRWAY 250 SERIES: DH
ITEM
PART NO.
1-49L
1-49R
1-50
1-53
*
*
1-54
*
*
1-55
*
*
1-57
1-58
*
*
1-59
1-64
1-65
1-66
1-67
1-68
1-69
1-70
1-71
1-72
1.73
1.74
1.75
MBG5538.07
MBG5537.07
2206131E.07
MBF0644F.07
MBG5363.07
MBE1265.07
148141-07
148138
64164-08
2206024H.07
MBG5362.07
MBE1265.07
35027N
64140-3
MBG6757.07
MBG5371.07
4138307
4140176
MBF1544A
008145530
4141565
452439
4140252
4151637
4193480
4192800
4188560
DESCRIPTION
PLATE MOTOR LH
PLATE MOTOR RH
FRAME FRONT
WLDMNT-FRAME RAIL RH
BRACKET LH
HOSE BRACKET
WHEEL MTR ME21 0208MBT
• SEAL KIT
• KEY
WLDMNT-FRAME RAIL LH
BRACKET RH
HOSE BRACKET
GREASE ZERK
COTTER PIN 3/32 X 3/4
HOSE COVER LH
HOSE COVER RH
WASHER
STEERING RAM
BOLT-MOTOR MOUNT
ROD END
SPACER(25x16.2x17.5Lg)
NUT-Hex M16 Flng Nyloc
PLATE-REAR MOTOR RH
HOSE BRACKETS
Hub
Hub Nut Lock
Capscrew M6 x 20
* Not Illustrated
QTY.
1
1
1
1
1
2
2
1
1
1
1
2
2
1
1
1
1
1
1
1
1
1
1
2
2
2
2
REMARKS
FOR HOSES REAR MOTORS
FOR HOSES REAR MOTORS
FOR HOSES REAR MOTORS
FOR HOSES REAR MOTORS
FAIRWAY 305 ONLY
FAIRWAY 305 ONLY
from s/n DH000560
from s/n DH000560
from s/n DH000560
Parts- 9
JACOBSEN FAIRWAY 250 SERIES: DH
ENGINE MOUNTING
Parts- 10
JACOBSEN FAIRWAY 250 SERIES: DH
ITEM
2-1
2-5
2-6
2-7
2-8
2-9
2-11
2-12
2-13
2-14
*
*
2-20
2-23
2-26
2-27
2-29
2-30
2-31
2-32
2-34
*
*
2-35
2-36
2-37
2-38
2-39
PART NO.
2208078
MBG6851
MBG6852
MBG6853
450030
450379
48380
64123-73
452200168
001599052
001021090
001599052
37410-88518
001990072
450214
450412
2202064
002994060
2202160A
001399105
4121697
4135618
001925570
4122690
450022
450390
450378
006911200
DESCRIPTION
ENGINE - V1305
ENGINE BRKT RH TURBO
ENGINE BRKT LH REAR TURBO
ENGINE BRKT LH FRONT TURBO
BOLT-HEX M10 X 40
NUT-HEX M1 0 NYLOC
MOUNT ISOLATION
SCRW-HEX 1/2-13 X 1
LOCKWASHER-1/2 X .763 X .116
WSHR-.526/.506 X 1-1/4 X 12GA
BLT-HEX 1/2"-13X 3/4"
WSHR-.526/.506 X 1-1/4 X 12GA
EXHAUST MUFFLER
U-CLAMP
SCRW-HEX M10 X 25
WSHR-SLW M10
BRACKET ENGINE MOUNTING
BUMPER STOP
STOP-REAR REEL
NUT NYLOC 3/8"
EXHAUST DOWNPIPE
SLEEVING
HOSE CLAMP 34-57MM
CHROME TAILPIPE
BOLT M8 X 70
M8 WASHER
M8 NYLOC
EXHAUST BAND
* Not Illustrated
QTY.
1
1
1
1
8
10
4
4
4
4
4
4
1
1
11
11
4
2
2
2
1
0.5
2
1
1
2
1
1
REMARKS
BOTTOM ENG MOUNT BOLTS
BOTTOM ENG MOUNT WASHERS
Parts- 11
JACOBSEN FAIRWAY 250 SERIES: DH
ENGINE/HYDRAULIC TRANSMISSION DRIVE
Parts- 12
JACOBSEN FAIRWAY 250 SERIES: DH
ITEM
3-1
3-1
3-2
3-3
3-4
3-5
3-6
3-7
3-8
3-9
3-10
3-11
3-12
3-13
3-14
3-15
3-16
3-17
*
3-18
3-19
3-20
3-21
3-21
3-22
PART NO.
DESCRIPTION
QTY.
REMARKS
4172803
4239642
COUPLING 15T, FBA
COUPLING 15T, DELTA SUPER 5
1
1
To S/N
From S/N
001290140
4196202
450391
450412
001191520
450390
450411
450015
450390
450411
450014
450392
452200168
800770
008006380
008008860
W158061-04
452200087
451110134
2208041
080080059
4176382
CAPSCREW-SCKT M10 X 1.25X 30
BELL HOUSING
WSHR-M10 X 21 X 2.2
WSHR-SLW M10 X 15.9 X 2.5
SCREW-HEX M10 X 1.25 X 35
WSHR-M8 X 17 X 1.8
WSHR-SLW M8 X 12.75 X 2
BOLT-HEX M8 X 35
WSHR-M8 X 17 X 1.8
WSHR-SLW M8 X 12.75 X 2
BOLT-HEX M8 X 30
WSHR M12
WSHR-SLW 1/2" X .768 X .116"
SCREW,.5-13 1.75 BS HS G8
TRANSMISSION PUMP
SEAL KIT FOR 008006380
O-RING 3.237 ID X .103 SECT
WSHR-SLW 3/8" X .590" X .092"
BOLT-HEX 3/8" UNC X 1-1/2"
TANDEM PUMP
TANDEM PUMP
BELL HOUSING KIT
3
1
2
5
2
1
1
1
3
3
3
2
2
2
1
1
1
2
2
1
1
1
PARTS ARE
INTERCHANGEABLE
CONSISTS OF ITEMS 1 & 4
* Not Illustrated
Parts- 13
JACOBSEN FAIRWAY 250 SERIES: DH
ENGINE PARTS
Parts- 14
JACOBSEN FAIRWAY 250 SERIES: DH
ITEM
4-1
*
*
*
*
*
*
*
*
*
*
*
*
*
*
*
*
PART NO.
2208078
16282-32112
13351-43010
15221-43080
16249-74287
16231-64010
16616-60010
006911340
2203099
450002
450410
4149737
16292-72001
16286-72851
16296-72941
36200-82721
15531-72403
19059-72091
DESCRIPTION
ENGINE - V1305B-15
OIL FILTER
IN-LINE FUEL FILTER
CARTRIDGE FUEL FILTER
FAN DRIVE PULLEY
ALTERNATOR
ELECTRIC STOP SOLENIOD
FAN 8 BLADE
SPACER, FAN
BOLT-HEX M6 X 35
WSHR-SLW M6
RADIATOR KIT
RADIATOR
HOSE-RADIATOR, LOWER
HOSE-RADIATOR, UPPER
CLAMP
EXPANSION BOTTLE
BREATHER PIPE EX KUBOTA
* Not Illustrated
QTY.
1
1
1
1
1
1
1
1
1
4
4
*
1
1
1
4
1
1
REMARKS
FOR RADIATOR HOSES
Parts- 15
JACOBSEN FAIRWAY 250 SERIES: DH
SERVO PUMP & THROTTLE CONTROLS
Parts- 16
JACOBSEN FAIRWAY 250 SERIES: DH
ITEM
5-1
5-2
5-3
5-4
5-5
5-6
5-7
5-10
5-11
5-13
5-14
5-15
5-16
5-17
5-19
5-20
5-21
5-23
5-24
5-25
5-26
5-27
5-28
5-30
5-32
5-33
5-34
5-35
5-36
5-37
5-38
5-39
PART NO.
456010161
002920501
172084
4145165
450411
450412
MBG2027A
450391
001190327
450191
452436
450390
450392
172088
H083031
450195
450324
W118047-02
MBF1971.07
W038404-02
MBF1691
450323
450000
MBF1720
128079
002910859
MBG4501.07
MBF1105A
450389
009067640
001393141
450388
DESCRIPTION
SCRW-HEX 5/16-24X1/2
DISC SPRING
CLAMP-THROTTLE
CABLETHROTTLE WITH T-PIECES
S.L. WASHER, M8
S.L. WASHER, M10
THROTTLE BRACKET
WASHER, M10
SCREW M10 X 20 1.25
SCRW, M8 X 20, HEX HD
NUT, M8 FLANGED
WASHER, M8
WASHER, M12
THROTTLE ARM
DISC SPRING
SCREW M8 X 40, HEX HD
NUT, M8
BUSHING SLIP LOK 1/2
THROTTLE LEVER ASSY CRANK
GRIP
COLLAR
NUT NYLOC M6
BOLT-HEX M6 X 25
CLAMPING COLLAR
ROD END, 1/4 FEMALE
SPRING
CABLE BRACKET
BOSS
WASHER M6
TRACTION CABLE
NUT M6
WASHER M5
* Not Illustrated
QTY.
REMARKS
1
2
1
1
1
1
1
1
1
1
1
1
1
1
2
2
4
1
1
1
1
1
1
1
1
2
1
1
2
1
1
1
Parts- 17
JACOBSEN FAIRWAY 250 SERIES: DH
FILTER MOUNTING
Parts- 18
JACOBSEN FAIRWAY 250 SERIES: DH
ITEM
6-1
6-2
6-3
6-4
6-4a
6-5
6-6
6-7
6-8
6-9
6-10
6-11
6-12
6-13
*
6-14
6-15
6-16
6-17
6-18
6-19
6-20
6-21
6-22
*
*
*
6-24
6-25
6-26
6-27
*
*
*
6-28
6-29
6-30
6-31
*
PART NO.
2198114
2198147
2198147-01
2198147-03
2198147-04
2198147-02
450191
450390
W178077
W178078
W178081
108086-05
450543
450389
450378
009135880
009135870
MBF2310
2198125
MBG6720
450528
450409
450322
2198112
450519
450408
450321
009100790
48383
48524
38665
450519
450408
450321
450378
450170
450410
450389
4117825
DESCRIPTION
CLAMP-AIR CLEANER
AIR CLEANER
FILTER ELEMENT
COVER
S-COVER CLIP
VALVE-DUST UNLOADER
SCRW-HEX M8 X 20
WSHR-M8 X 17 X 1.8
SIGHT BOWL
FILTER-COALESCER
ASSY-FILTER HEAD
FITTING
SCRW-PAN HD M6 X 25
WSHR-M6 X 12.5 X 1.8
NUT-NYLOC M8
SIDE PANEL RH ASSY
SIDE PANEL LH ASSY
LANDING PANEL W/ASSY
BUMPER STOP
BRACKET, HOOD LATCH
SCRW-PAN HD M5 X 16
WSHR-SLW M5
NUT-HEX M5
LATCH, HOOD
SCRW-PAN HD M4 X 16
WSHR-SLW M4
NUT-HEX M4
AIR INLET HOSE
HOSE CLAMP
BREAKER 40 AMP
SOLENOID
SCRW-PAN HD M4 X 16
WSHR-SLW M4
NUT-HEX M4
NUT-NYLOC M8
SCREW-HEX M6 X 16
WSHR-SLW M6
WSHR-M6 X 12.5 X 1.8
HEAT INSULATION 200x250
* Not Illustrated
QTY.
1
1
1
1
1
1
6
10
1
1
1
2
2
2
2
1
1
1
3
1
4
4
4
1
4
4
4
1
2
1
1
4
4
4
8
6
6
6
1
REMARKS
(INCLUDES ITEMS 3 - 5)
HARDWARE FOR HOOD LATCH
HARDWARE FOR ELEC COMPS
2 FOR A/CLEANER CLAMP
Parts- 19
JACOBSEN FAIRWAY 250 SERIES: DH
STEERING WHEEL & PEDAL MOUNTING
Parts- 20
JACOBSEN FAIRWAY 250 SERIES: DH
ITEM
7-1
7-2
7-3
7-4
7-5
7-6
7-7
7-8
7-9
7-10
7-11
7-15
7-16
7-18
7-19
*
7-22
7-23
7-24
7-25
7-26
7-27
7-28
7-29
7-30
7-31
7-32
7-33
7-34
7-35
7-36
7-37
7-38
7-39
*
*
7-40
7-41
7-42
7-43
7-44
7-45
7-46
PART NO.
450213
452692
64001-8
W038124-01
009050490
450377
2203070.07
2206029G.07
2202159.07
450214
008109660
W64175-04
2203067
2202149.07
2202150.07
MBG5314.07
W128025-04
W128025-03
2202154.07
2203069
2202148A.07
001490006
450019
450020
450324
2202161.07
450379
64209-07
38383
699527153
MBF0654A
MBF1280
001290379
128079
002910859
MBG4471.07
001925160
148263
009067640
W43067A
MBG5073
2196117
146082
DESCRIPTION
SCRW-HEX Ml 0-1.5 X 20
SCREW-M6 X 12 HEX TAPTITE
NUT-HEX JAM 112-13
KNOB
PANEL INSTRUMENT COMPLETE
LOCKNUT NYLOC M6-1 .00
ROD-BRAKE RELEASE
STEERING TOWER W/ASSY
GUIDE-BRAKE ROD
BOLT MlO-1.5X25
HOURMETER
PUSH NUT 3/8 DIA
PIN-BRAKE
BRKT BRAKE LH
BRKT BRAKE RH
BRACKET
CABLE-BRAKE
CABLE-BRAKE1
LATCH-BRAKE1
PIN-BRAKE PEDAL
RELEASE-BRAKE
COTTER PIN
BOLT-HEX M8-1 .25 X 55
BOLT-HEX M8-1 .25 X 60
NUT HEX M8-1 .25
BRACKET-SPEED CONTROL
LOCKNUT NYLON Ml 0-1.5
WASHER, CONICAL Ml 0
SWITCH
SPRING-EXTENSION
COLLAR-SET 3/8 ID
WLDMT-NEUTRAL CONTROL
SETSCREW 1/4-20X114
ROD END
SPRING
CABLE BRACKET
JUBILEE CLIP
FUEL LINE
TRACTION CABLE
COLLAR, SET PLATE
BEARING BLOCK
FWD/REV PED W/MAT
PEDAL ADAPTER W/MAT
* Not Illustrated
QTY.
REMARKS
3
4
1
1
1
4
1
1
1
2
1
2
1
1
1
1
1
1
1
1
1
2
1
1
4
1
6
2
1
1
2
1
4
1
1
1
4
1
1
2
2
1
1
Parts- 21
JACOBSEN FAIRWAY 250 SERIES: DH
STEERING WHEEL & PEDAL MOUNTING
Parts- 22
JACOBSEN FAIRWAY 250 SERIES: DH
ITEM
7-47
*
*
7-50
*
*
*
*
7-51
7-52
7-53
7-55
7-56
7-58
7-59
7-60
7-61
7-62
7-63
7-64
7-65
7-66
7-67
7-68
7-69
7-70
7-71
*
7-73
7-76
7-77
7-78
7-79
7-80
7-81
7-82
7-83
7-84
7-85
7-86
7-87
7-88
7-89
*
PART NO.
001190377
452200029
452000211
2208142
2208142-01
2208142-02
2208142-03
2208142-04
009135950
450542
450410
450377
450170
172304.07
001594080
173006
001419072
64166-17
W118047-02
172042A.07
178138
172298.07
176100.07
001496248
001393117
450120267
2198130
64061-26
839862
W38382
450151
450378
2202117.07
2206054
2198129
48436
48013-06A
450323
450003
2208052
MBF0838A
2208099
MBE3313C.07
450605
DESCRIPTION
BLT-WLF 1/4"-20 X 1/2"
WSHR-SLW 1/4" X .425 X .072"
WSHR- 1/4" X 9/16" X 0.56"
VALUE POWER STEERING
• SEAL KIT
• BEARING KIT
• CAP KIT
• RELIEF VALUE
FRONT TOWER COVER
SCRW-PAN M6 X 20
WSHR-SLW M6
NUT NYLOC M6
SCREW-HEX M6 X 20
BRACKET-TILT WHEEL
WASHER .516 ID
SHAFT LOCKING
ROLL PIN
SHOULDER BOLT
BUSHING, FLIP LOK 1/2
BRKT-STEERING
WASHER-FRICTION
SUPPORT-STEERING
WLDMT FRICTION WASHER
ROLL PIN
NUT- 5/16-18
LOCKNUT
STEERING WHEEL
ROLL PIN
S-LOGO COVER
SWITCH N/O
SCREW-HEX M5 X 16
NUT NYLOC M6
BACLKAP SWITCH BRACKET
BRAKE PEDAL
MAT-NON SKID
MAT,NON SKID
MAT, NON SKID
NUT-HEX M6
BLT-HEX M6 X 40
MAT-PLATFORM
BUSHING-BRAKE
FOOT SWITCH
PAD ASSEMBLY FOR FOOT SW
SCREW-CSK M5 X 12
* Not Illustrated
QTY.
2
2
2
1
1
1
1
1
1
2
2
1
1
1
1
I
1
2
2
1
2
1
1
1
4
2
1
1
1
1
2
2
1
1
1
1
1
1
4
1
2
1
1
2
REMARKS
(INCLUDES ITEM 73)
Parts- 23
JACOBSEN FAIRWAY 250 SERIES: DH
STEERING WHEEL & PEDAL MOUNTING
Parts- 24
JACOBSEN FAIRWAY 250 SERIES: DH
ITEM
PART NO.
*
*
7-93
473
479
1648
1649
1650
1651
*
1648
1649
450388
450376
450001
450378
450390
4123144
4124120
450553
450192
MBG5314.07
4139003
4139004
DESCRIPTION
WASHER M5
NUT NYLOC M5
BOLT-HEX M6 X30
NUT NYLOC, M8
WASHER, M8
BUMP STOP BRACKET
RUBBER STOP
CAP SCREW, M8 x 25
SCREW, M8 x25
SUPPORT BRKT FR BUMP STOP
BUMP STOP BRACKET
RUBBER STOP
* Not Illustrated
QTY.
2
2
1
4
2
1
1
2
2
1
1
1
REMARKS
AFTER DH 000250
AFTER DH 000250
Parts- 25
JACOBSEN FAIRWAY 250 SERIES: DH
FRONT LIFT ARM MOUNTING
Parts- 26
JACOBSEN FAIRWAY 250 SERIES: DH
ITEM
PART NO.
6-1
6-2
6-3
6-4
*
6-5
6-6
6-7
6-8
6-9
6-10
6-11
6-12
6-13
6-14
6-15
6-16
6-17
6-21
6-22
6-23
6-24
6-25
6-26
6-28
64144-13
2203048-02
2202170.07
2208151
198040-01
85010N
450170
2206032
450377
2206016A.07
W108003
MBF0199J.07
450379
450215
2206051.07
001393820
2206004B.07
MBG1842.07
64163-74
450038
450378
2202096.07
450192
158001-06
001594010
*
*
*
6-30
*
6-31
6-32
6-33
6-34
6-35
6-36
6-37
6-38
6-40
6-41
6-42
6-43
6-44
MBC1561A
001490006
450391
2208152
198040-01
2206017B.07
450038
2206057.07
450034
62464-4A
W68160A
148090-02
2206018A.07
2202171A.07
2203083A
450018
2203047.07
2202169A.07
DESCRIPTION
SNAP RING
PIN-REEL CYLINDER
PLATE-LIFTSTOP
LIFT RAM
• SEAL KIT
LUBRICATOR GREASE FITTING
SCREW-HEX M6 X 16
WLDMT-CYLINDER PIN
NUT M6
REEL ARM FRONT LH
BUSHING
FRONT FRAME (305 / 405)
LOCKNUT-NYLOC M10
SCREW, M10 X 30 HH
WLDMT-PIVOT PIN REAR
NUT HEX 1-1/4-12 NYLOC
YOKE 22" C/U
ASSY, PIVOT SHAFT
WASHER
BOLT M10 X 80
LOCKNUT M8
STOP-REEL PIVOT
SCREW M8 X 25
CHAIN
WASHER
CHAIN TO CUTTING UNIT
PIN - CHAIN TO UNIT
SPRING CLIP - FOR MBC1561A
WASHER M10 - FOR MBC1561A
LIFT RAM
• SEAL KIT
FRONT CENTER REEL ARM
BOLT-METRIC M10 X 80
WLDMT-PIVOT LEVER
BOLT-HEX M10 X 60
THRUST WASHER
SPOUT HANDLE GRIP
SUPPORT, TUBE 3/4
FRONT REEL ARM RH
PLATE-LIFTSTOP
SLEEVE CYLINDER
BOLT M8 X 50
RETAINER-REEL
LIFTSTOP-LH
* Not Illustrated
QTY.
REMARKS
6
3
2
2
1
2
6
3
3
1
A/R
1
5
2
3
3
5
3
3
3
15
6
6
3
3
3
3
3
1
1
2
2
1
A/R
2
4
1
2
3
5
5
2
Parts- 27
JACOBSEN FAIRWAY 250 SERIES: DH
FRONT LIFT ARM MOUNTING
Parts- 28
JACOBSEN FAIRWAY 250 SERIES: DH
ITEM
6-45
6-46
6-47
6-48
6-49
6-50
6-51
6-52
6-53
6-54
6-55
6-56
*
*
*
6-58
6-59
*
*
*
6-60
6-62
6-80
6-81
6-82
6-83
6-84
6-85
PART NO.
2202168A.07
2208067
64251-003
64188-02
64168-2
2202172.07
450192
GSF2152A
A299301
W048048A
35027N
2202173.07
MBG1827A.07
450151
450322
MBG4566.07
W038383
450151
450409
450322
2202209.07
2203048-02
4118433
W38382
450526
452692
450388
450376
DESCRIPTION
LIFTSTOP-RH
BUMPER-RUBBER
WASHER
CLEVIS PIN
HAIRPIN COTTER
LIFT LEVER-FOOT
SCREW M8 X 25
WASHER
LUBRICATOR GREASE FITTING
SLEEVE BEARING
LUBRICATOR GREASE FITTING
PLATE-LIFTSTOP BACKING
MOTOR GUARD (RH CUTTING UNIT)
SCREW, M5 X 16, HEX HD
NUT, M5
SWITCH BRACKET
SWITCH
SCREW, M5 x 16, HEX HD
S.L.WASHER, M5
NUT, M5
STOP PLATE
PIN-REEL CYLINDER 108.37LG
SWITCH BRACKET
SWITCH
SCRW-PAN HD M5 x 12
SCRW-HEX M6 x 12 TAPTITE
WASHER-M5 x 10 x 1.1
NUT-HEX M5 NYLOC
* Not Illustrated
QTY.
2
2
12
2
2
1
12
3
3
6
1
1
1
2
2
1
1
2
2
2
4
1
1
1
2
2
2
2
REMARKS
(USE ON CENTRE UNIT)
FITTED TO ITEM 50
Parts- 29
JACOBSEN FAIRWAY 250 SERIES: DH
REAR LIFT ARM MOUNTING
Parts- 30
JACOBSEN FAIRWAY 250 SERIES: DH
ITEM
9-1
9-2
9-3
9-4
9-5
9-6
9-7
9-8*
9-9
9-10
9-11
9-12
9-13
9-14
9-15
9-16
9-17
9-18
9-19
9-22
9-23
9-24
9-25
7-26
9-32
9-33
9-34
9-35
9-36
*
9-37
9-38
9-39
9-40
9-41
9-42
9-43
9-44
9-48
*
*
*
9-49
9-50
PART NO.
450392
450048
2206204
450380
2202146
450241
W108003
2206019.07
2206020.07
842000044
2206051.07
450214
2202092A.07
450015
450380
450379
MBG5612.07
001393820
62464-4A
W158001-05
23009A.07
450378
2202209.07
MBG1842.07
2206032.07
450170
64144-13
2203048-03
2208152
198040-01
2203083A
148034-05
GSF2152A
002993010
450018
2203047.07
2206004B.07
48048A
MBF0744-07
450192
450390
450378
2202160A
002994060
DESCRIPTION
WASHER-M12
BOLT M12 x 40
WLDMT-FRAME REAR
NUT-NYLOC M12
PLATE
BOLT M12 X 30
BUSHING
LIFT ARM, RIGHT REAR
LIFT ARM, LEFT REAR
1/4" STRAIGHTGREASE NIPPLE
WLDMT-PIVOT PIN REAR
BOLT M10 X 25
BRACE-REAR REEL
BOLT M8 X 35
NUT-NYLOC M12
NUT NYLOC M10
BRKT-REAR ARM
NUT-HEX 1-1/4-12 NYLOC
THRUST WASHER
CHAIN 6.7 LG PLATED
SPACER, ENGINE MOUNT
NUT NYLOC M8
STOP-REEL PIVOT
ASSY, PIVOT SHAFT
WLDMT-CYLINDER PIN
SCREW-HEX M6 X 16
SNAP RING
PIN-REEL CYLINDER
CYLINDER-REEL SHORT
• SEAL KIT
SLEEVE-CYLINDER
GROMMET-INSULATION
WASHER
LUBRICATOR
BLT MET M8 X 50
RETAINER-REEL
DECK PIVOT
SLEEVE BEARING
REAR ARM STOP
SCREW-HEX M8 X 25
WASHER M8
NUT-NYLOC M8
STOP-REAR REEL
RUBBER MOUNT
* Not Illustrated
QTY.
4
2
1
4
1
6
8
1
1
6
2
9
2
2
4
10
1
2
AR
2
2
6
2
2
2
2
4
2
2
1
2
2
2
2
2
2
2
4
2
4
4
4
2
2
REMARKS
(INCLUDES ITEM 7)
(INCLUDES ITEM 7)
(INCLUDES ITEMS 10, 44 & 52)
FITTED TO CHASSIS SIDES
Parts- 31
JACOBSEN FAIRWAY 250 SERIES: DH
REAR LIFT ARM MOUNTING
Parts- 32
JACOBSEN FAIRWAY 250 SERIES: DH
ITEM
PART NO.
9-60
2203098
*
*
*
MBC1561A
001490006
450391
DESCRIPTION
SPACER-CYLINDER
CHAIN TO CUTTING UNIT
PIN
SPRING CLIP
WASHER M10
* Not Illustrated
QTY.
REMARKS
2
2
2
2
Parts- 33
JACOBSEN FAIRWAY 250 SERIES: DH
DRIVE WHEELS & BRAKES
Parts- 34
JACOBSEN FAIRWAY 250 SERIES: DH
ITEM
PART NO.
10-1
10-2
10-3
10-4
10-5
10-6
10-7
10-8
10-9
10-10
10-11
450379
699527153
2206031
W128025-03
64144-30
2206032.07
MBF1283
001599688
450391
450215
008007150
002301080
450052
008007460
W178013
MBG3598
MBF0838A
64123-15
64006-04
172060
W2171004A
451264
008007470
2208290
2208291
2208065-02
W128025-04
64220-01
MBF1907.07
MBG5305
450191
450411
450390
10-12
10-13
10-14
10-15
10-16
10-17
10-18
10-19
10-20
10-21
10-22
10-23
10-24
10-25
10-26
10-27
10-30
10-31
10-32
10-33
10-34
DESCRIPTION
NUT-NYLOC M10
SPRING
WLDMT-BRAKE ARM
CABLE, BRAKE
SNAP RING .375
WLDMT-BRAKE ARM
SPACER
WASHER
WASHER
SCREW M1O X 30
WHEEL MOTOR MJ29
• SEAL KIT
BOLT-M12-1.75X50
SQUARE KEY
BRAKE BAND
BOLT M10 x 45
BUSHING - BRAKE
BLT HEX 3/8-16 X 3/4
LOCKWASHER
BRAKE DRUM
HUB
COTTER PIN
CASTLE NUT
ASM WHL &TYRE 26.5X14-12
• RIM W/VALVE STM & CAP
• TYRE 26.5 X 14
CABLE-BRAKE
BLT-WHL 1 2-20X.880D
STOP-BRAKE BAND
KEEP BRACKET
SCRW-HEX M8 X 30
WASHER SLW M8
WASHER M8
* Not Illustrated
QTY.
2
4
2
1
2
2
4
12
2
2
2
1
8
2
2
4
2
8
8
2
2
2
2
2
AR
AR
1
10
2
2
4
4
4
REMARKS
(USE FOR LEFT HAND BRAKE)
Torque 290Nm
(USE FOR RIGHT HAND BRAKE)
Torque 80Nm
Parts- 35
JACOBSEN FAIRWAY 250 SERIES: DH
HYDRAULIC RESERVOIR & FUEL TANK
31
22
7
8
8
50
30
7
7
26
29
42
43
36
24
20
34
15
27
1
35
41
44
43
19
51
18
21
34
33
38
49
27
37
28
2
3
39
5
4
37
7
40
15
32
10
6
23
45
37
20
7
19
18
9
10
15
17
7
20
15
19
11
18
16
7
15
Parts- 36
8
12
13
14
46
8
JACOBSEN FAIRWAY 250 SERIES: DH
ITEM
11-1
11-2
11-3
11-4
11-5
11-6
11-7
11-8
11-9
11-10
11-11
11-12
11-13
11-14
11-15
11-16
11-17
11-18
11-19
11-20
11-21
11-22
11-23
11-24
11-25
11-26
11-27
11-28
11-29
11-30
11-31
11-32
11-33
11-34
11-35
11-36
PART NO.
64152-05
450409
2208073
W148081
W178105
178105-01
2208109
450390
450191
2202129C.O7
2208054
450020
2206049B.07
2206050B.07
2208071
450378
2202138.07
2206131E.07
450213
450412
450391
450377
2202166A.07
2208031
2202103.07
148263
MBG4553.07
450388
2198091
008230310
2208034
450541
2202128C.07
W178142
450528
450376
4180161
DESCRIPTION
10-32 X 1/2 MACH SCREW
LOCKWASHER M5
SENDER-FUEL LEVEL
GASKET
CAP-LOCKING
• KEY
TANK-FUEL FWAY
WASHER M8
SCREW M8 X 20
STEP LH
MAT-STEP
BOLT M8 X 60
STEP LH LOWER
STEP RH LOWER
MAT-STEP
NUT NYLOC M8
PLATE-STEP CLAMP
FRONT FRAME
HEX BOLT M10 X 20
LOCKWASHER M10
WASHER M10
NUT NYLOC M6
PLATE-RESERVOIR COVER
RESERVOIR-HYDRAULIC
HOLD DOWN-BATTERY
FUEL PIPE
HINGE-RESERVOIR
WASHER
BOOT, FUEL SENDER
BATTERY TYPE 093
COVER-HYD RESERVOIR
SCRW-PAN M6 X 16
STEP RH
LATCH-RUBBER
SCREW PAN M5 X 16
NUT NYLOC M5
BREATHER
* Not Illustrated
QTY.
REMARKS
5
5
1
1
1
1
1
20
12
1
2
4
1
1
1
16
2
1
10
10
10
2
2
1
1
1
1
4
I
1
1
2
1
1
4
4
1
Parts- 37
JACOBSEN FAIRWAY 250 SERIES: DH
HYDRAULIC RESERVOIR & FUEL TANK
31
22
7
8
8
50
30
7
7
26
29
42
43
36
24
20
34
15
27
1
35
41
44
43
19
51
18
21
34
33
38
49
27
37
28
2
3
39
5
4
37
7
40
15
32
10
6
23
45
37
20
7
19
18
9
10
15
17
7
20
15
19
11
18
16
7
15
Parts- 38
8
12
13
14
46
8
JACOBSEN FAIRWAY 250 SERIES: DH
ITEM
PART NO.
11-37
11-38
11-39
11-40
11-41
11-42
11-43
11-44
11-45
11-46
11-47
11-48
11-49
11-50
11-51
108094-06
008296050
69051-01
108029
158122-02
148231
48310
2208031-01
158065-03
MBG4795
001925160
148263
64211-02
450389
4132325
DESCRIPTION
CLAMP
SWITCH-TEMPERATURE 175F
PIPE PLUG
PLUG, MAGNETIC
TUBING-SIGHT CLASS 8"
S-ELBOW-90 3/16 FINING
S-BUSHING
FTG-3/1 6 BARB STRAIGHT
FTG - 13/16-16/112-14
MAT-STEP
HOSE CLIP
FUEL PIPE
WASHER 3/16"
WASHER M6
GROMMET
* Not Illustrated
QTY.
REMARKS
4
1
1
1
1
1
2
1
1
1
2
1
5
2
1
Parts- 39
JACOBSEN FAIRWAY 250 SERIES: DH
RADIATOR & OIL COOLER MOUNTING
Parts- 40
JACOBSEN FAIRWAY 250 SERIES: DH
ITEM
PART NO.
DESCRIPTION
12-1
12-1
12-2
*
*
12-3
*
12-4
12-5
12-6
12-7
12-8
12-9
12-10
12-11
*
12-12
12-13
12-14
12-15
*
12-16
*
*
*
12-17
12-18
12-19
12-20
12-21
006911620
4196940
4116484
008089820
4115389
009001840
PF24-113
002990293
450378
002989450
MBG7109
450168
450410
450389
MBF2385
MBG7108
002989450
MBF2384
MBF2276
15531-72403
19059-72091
4149737
4117044
002600640
4150377
4116801
4116947
001925400
001925570
48383
OIL COOLER (SETRAB)
1
OIL COOLER (THERMAL TRANSFER) 1
FITTING - 90 deg 1"BSPP x 1-1/4"
2
HOSE CLAMP
2
OIL COOLER HOSE
2
BUGSCREEN
I
SEALING STRIP
1.5
M8 HANDKNOB
2
NUT-HEX M8 NYLOC
2
SEALING STRIP
1
OIL COOLER SEALING STRIP
1
SCRW-HEX M6 X 12
11
WSHR-SLW M6
13
WSHR-M6 X 12.5 X 1.8
13
BAFFLE PLATE W/ASSY
1
305 RAD SEAL
2
SEALING STRIP
1
WLDMT-REAR AXLE
1
EXP. BOTTLE BRKT W/A
1
EXPANSION BOTTLE
1
BREATHER PIPE EX KUBOTA
1
RADIATOR
1
3/8" BSPP DRAIN PLUG
1
3/8" DOWTY WASHER
1
RADIATOR SEAL
2
HOSE-RADIATOR, UPPER
1
HOSE-RADIATOR, LOWER
1
HOSE CLAMP 19-40
2
HOSE CLAMP 34-57
2
HOSE CLAMP 2-1/2"
2
12-22
12-23
12-24
12-25
12-26
4116202
002989450
002989450
008955160
450168
AIR INTAKE HOSE
SEALING STRIP
SEALING STRIP
GROMMET
SCRW-HEX M6 X 12
* Not Illustrated
QTY.
1
2
2
1
4
REMARKS
1 PER ITEM 2
CONNECT TO ITEM 2
1.5m REQUIRED
600 LONG
1270 LONG
FOR DRAIN PLUG
FOR RADIATOR HOSES
FOR RADIATOR HOSES
ONE PER END, OTHER AIR
CLEANER.
42" LONG
510 LONG
250 LONG
DRAIN PLUG REAR BOX
RADIATOR MOUNTING SCREWS
Parts- 41
JACOBSEN FAIRWAY 250 SERIES: DH
BONNET HINGE ARRANGEMENT / REAR BUMPER
Parts- 42
JACOBSEN FAIRWAY 250 SERIES: DH
ITEM
13-1
13-2
*
*
13-3
13-4
13-5
13-6
13-7
13-8
13-11
13-12
13-15
13-16
13-17
13-18
13-19
13-20
13-21
13-22
13-23
13-24
13-30
13-31
PART NO.
001496133
009135850
4116171
009040260
2198112
450029
450215
450391
450412
452437
MBG6792
MBG6794
MBG6824
MBG7076
009135840
450171
450377
450389
MBF2299
450542
450410
452101667
MBG7112
MBG7111
DESCRIPTION
POP RIVET
BONNET
BONNET SEALING STRIP
BONNET SEAL FOAM
LATCH
BOLT-HEX M10 X 35
SCRW-HEX M10 X 30
WSHR-M10 X 21 X 2.2
WSHR-SLW M10
NUT-NYLOC M10 FLNG
HINGE BRKT-SHORT
HINGE BRKT-LONG
BONNET BRACKET
BONNET SPACER
REAR BUMPER
SCRW-HEX M6 X 20
NUT-HEX M6 NYLOC
WSHR-M6 X 12.5 X 1.8
HINGE SEALING W/ASSY
SCRW-PAN HD M6 X 20
WSHR-SLW M6
WSHR-1/4" X 1"
HINGE BRKT-SHORT
HINGE BRKT-LONG
* Not Illustrated
QTY.
2
1
1
1
1
14
4
18
4
14
4
4
1
AR
1
4
4
6
1
6
6
4
4
4
REMARKS
RUBBER INSERTION FOAM
CLOSED CELL FOAM
Parts- 43
JACOBSEN FAIRWAY 250 SERIES: DH
SEAT MOUNTING
23
1c
Parts- 44
JACOBSEN FAIRWAY 250 SERIES: DH
ITEM
PART NO.
DESCRIPTION
15-1a
15-1b
15-2
*
*
*
15-3
15-4
15-5
15-6
15-7
15-8
15-9
15-10
15-11
15-12
15-13
15-14
15-15
15-16
15-17
15-18
15-19
15-20
15-21
15-22
15-23
4137966
008199400
MBF0603B.06
450214
450391
450412
2208075
2202118.07
MBG2013.07
450191
450390
450389
450172
469016517
450377
450378
002953223
450411
450192
450214
450391
450379
001599264
001393222
W64166-03
MBF1605
4142205
SEAT, GRAMMER MSG85
SEAT, GRAMMER S85/90R
SEAT PLATE W/A
SCREW M10 X 25
WASHER M10
LOCKWASHER M10
LATCH-ADJUSTABLE LEVER
SEAT SUPPORT
SEAT HINGE
SCRW-HEX M8 X 20
WASHER M8
WASHER M6
SCRW-HEX M6 X 25
P-CLIP
NYLOC M6
NYLOC M8
GROMMET
WASHER SLW M8
SCRW-HEX M8 X 25
SCRW-HEX M10 X 25
WSHER M10
NYLOC M10
3/8" WASHER
3/8" NYLOC
SHOULDER BOLT 3/8"
SPACER
RETRACTING LAP BELT
1
1
1
2
2
2
2
2
2
8
17
1
1
1
1
8
1
4
4
2
2
2
2
2
2
1
1
*
*
*
450392
456010967
4176261
WASHER M12 X 24 X 2.7
SCREW, HEX 7/16-20 X 1
SPACER 12 X 18 X 9
2
6
2
* Not Illustrated
QTY.
REMARKS
SEAT PLATE TO FRAME
SEAT PLATE TO FRAME
SEAT PLATE TO FRAME
FOR USE WITH ROPS FRAME OR
CAB
FOR ITEM 23
FOR ITEM 23
FOR ITEM 23
Parts- 45
JACOBSEN FAIRWAY 250 SERIES: DH
SEAT GRAMMER MSG 85 SEAT (4137966) - SUSPENSION
Parts- 46
JACOBSEN FAIRWAY 250 SERIES: DH
ITEM
5
6
11
15
16
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
35
36
37
38
39
40
41
42
43
44
45
46
47
52
53
55
57
58
59
60
PART NO.
008173680
008173790
008173800
008199900
008173780
008173820
008173830
008173840
008173710
008199680
008173720
008173740
008173760
008173730
008173870
008144410
008173880
008173910
008173930
008173950
008193960
008193920
008173940
008174000
DESCRIPTION
Cover
Kit, Suspension Upper
Kit, Bellow
Bolt
Bushing
Swing Arm Kit
Bolt
Roller
Plate
Tension Spring
Release Plate
Bolt
Bolt, M8 x 22, Yellow
Kit, Shock Absorber, S
Washer, Retaining, 5 mm
Fork
Rivet, 4.0 x 10.0
Bracket, U-Shaped Pro
Rubber Plate
Bumper Set
Thrust Washer Kit
Spring, Tension
Nut, M12, Flange
Spring Bracket
Plug, Retainer
Pin, 3.0 x 16
Pin, 4 x 28
Handle (Toggle)
Adjustment Spindle
Guide
Roller
Band, Weight, 130 kg
Tension Spring
Bushing
Suspension Lower Par
Fixing Parts
Suspension MSG85
Screw, M6 x 12
Ties, Cable, 2.5 x 102
Switch
Connector, Electrical
* Not Illustrated
QTY.
REMARKS
1
1
1
1
4
1
1
4
1
2
2
1
2
1
2
1
2
1
1
1
1
2
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
2
2
1
1
Parts- 47
JACOBSEN FAIRWAY 250 SERIES: DH
SEAT GRAMMER MSG 85 SEAT (4137966) -SEAT TOP
Parts- 48
JACOBSEN FAIRWAY 250 SERIES: DH
ITEM
1
2
3
4
5
7
8
22
23
24
25
26
27
28
29
33
34
35
36
37
38
39
40
42
44
46
48
49
54
67
*
68
69
88
89
PART NO.
113048
DESCRIPTION
Assy, Cushion, Backrest
Assy, Cushion, Seat
Screw, M5 x 25, Pan Hd
Seat Pan
Backrest Pan Kit
Tube
Backrest Extension
Tube
Screw, M8-1.25 x 40
Rivet, 6 x 12
Nut, Hex, M8-1.25
Nut, Hex, M8-1.25
Lever
Handle, Grey
Cover, LH, Blk
Cover, RH, Blk
Screw M8 x 16
Set of Adjustment Rails
Nut, Hex M8-1.25
Washer, Flat, M8
Washer 8.4-Hv140
Kit, Seatbelt, 2 Retractable
Seatbelt, 2 Non-retractable
Spring, Spiral
Stop
Bearing Kit
Spring, Leg, Backrest
Set of Adjustment Rails
Screw, M8 x 16, Hex Socket
Literature Box
Literature Holder (net)
Blind Rivet 3.2 x 11.2
Ball
Armrest
Armrest
* Not Illustrated
QTY.
1
1
7
1
1
2
1
2
2
1
6
2
1
1
1
1
4
1
4
11
6
1
1
1
1
1
1
1
4
1
1
5
5
1
1
REMARKS
One supplied
Parts- 49
JACOBSEN FAIRWAY 250 SERIES: DH
SEAT GRAMMER (S 85 / 90R)
Parts- 50
JACOBSEN FAIRWAY 250 SERIES: DH
ITEM
16-1
16-2
16-3
16-4
16-5
16-6
16-7
16-8
16-9
16-10
16-11
16-12
16-13
16-14
16-15
16-16
16-17
16-18
16-19
16-20
16-21
16-22
16-23
16-24
16-25
16-26
16-27
16-28
16-29
16-30
16-31
16-32
16-33
16-34
16-35
16-36
16-37
16-38
16-39
16-41
16-42
16-43
PART NO.
008199400
008199450
008199460
008199560
008199470
008173520
N/A
008199610
008173370
008173380
008173390
008173400
008173410
008173420
008173430
008173440
008199690
008173450
008173460
008173470
008173480
008173490
008173500
008173510
008173530
008173540
008199650
008199660
008173550
008199670
008173560
008173570
008173350
008173360
008199860
008173580
008199640
008173590
008173600
008199750
008173610
008173620
008199700
DESCRIPTION
SEAT ASSY COMPLETE
SEAT CUSHION
BACK REST CUSHION
HEAD REST ASSY.
HEAD REST CUSHION
EDGE STRIP
HEAD REST FRAME
COVER RH
NUT
MOUNTING RH
SCREW
SCREW
SP WASHER
DISTANCE PLATE
DISTANCE PLATE
BUSH
BACK PLATE
TUBE
SPRING
WASHER
SCREW
TUBE
EDGE STRIP
EDGE STRIP
DISTANCE PIECE
SEAT PLATE
PIN
DETENT
MOUNTING LH
ROD
BUSH
DISTANCE PIECE
LEVER
SPRING
HANDLE
COVER LH
RAIL WITH LEVER
WASHER
SCREW
RAIL
PLATE
PLATE
NUT
* Not Illustrated
QTY.
1
1
1
1
1
1
1
1
2
1
4
2
2
2
1
2
1
1
1
2
2
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
4
4
1
1
1
1
REMARKS
INCLUDING SUSPENSION
Parts- 51
JACOBSEN FAIRWAY 250 SERIES: DH
SEAT GRAMMER (S 85 / 90R)
Parts- 52
JACOBSEN FAIRWAY 250 SERIES: DH
ITEM
16-44
16-45
16-46
16-47
16-48
16-49
16-50
16-51
16-52
16-53
16-54
16-55
16-56
16-59
16-60
16-61
16-62
16-63
16-64
PART NO.
008199710
008199720
008199730
008199740
N/A
008199550
N/A
N/A
N/A
008199850
008173630
N/A
008199860
N/A
N/A
N/A
N/A
N/A
N/A
DESCRIPTION
PIN
PIN
ADJUSTING SPINDLE
WASHER
PLUG
ARM REST RH
SCREW
SUPPORT RH
PIN
ARM REST ASSY. RH
ARM REST LH
SUPPORT LH
ARM REST ASSY. LH
COVER ASSY
SCREW
SEAT BELT FIXED
SEAT BELT REEL
SCREW
WASHER
* Not Illustrated
QTY.
REMARKS
1
1
1
1
2
1
2
1
2
1
1
1
1
1
1
1
1
Parts- 53
JACOBSEN FAIRWAY 250 SERIES: DH
SEAT SUSPENSION GRAMMER DS85H
Parts- 54
JACOBSEN FAIRWAY 250 SERIES: DH
ITEM
17-1
17-2
17-3
17-4
17-5
17-6
17-7
17-8
17-9
17-10
17-11
17-12
17-13
17-14
17-16
17-17
17-18
17-19
17-20
17-22
17-23
17-24
17-25
17-26
17-27
17-28
17-29
17-30
17-31
17-32
17-33
17-34
17-35
17-36
17-37
17-38
17-39
17-40
17-41
17-42
17-43
17-46
17-47
PART NO.
008173640
008173650
008173660
008199640
008199750
008173670
008173680
008173690
008173700
008199790
008199840
008173710
008173720
008199680
008173730
008173740
008173750
008173760
008173770
008173780
008173790
008173800
008173810
008173820
008173830
008173840
008173850
008199900
008173860
008173870
008173880
008173890
008173900
008199920
008199410
008173910
008173920
008173930
008173940
008173950
008173960
008173970
008173980
DESCRIPTION
SCREW
STOP
WASHER
SLIDE WITH LEVER
SLIDE
NUT
COVER
BASE ASSY.
PLATE
PIN
GAITER ASSY.
PIN
E CLIP
DAMPER ASSY
BUFFER ASSY.
RIVET
RUNNER
PLATE
SUSPENSION ASSY.
ROLLER
PIN
BUSH
SPRING
PLATE
PLATE
BOLT
PIN
HINGE
WASHER
BEARING
NUT
HANDLE
LEVER ASSY.
WEIGHT ADJUSTER
SPRING
SPRING HOOK
WEIGHT INDICATOR
STOP
SPRING
WINDOW
ROLLER
FORK
SPRING FRAME
* Not Illustrated
QTY.
REMARKS
6
1
2
1
1
6
1
1
2
21
1
2
2
1
1
2
1
1
1
4
1
4
2
1
2
1
1
1
1
1
1
1
1
1
2
1
1
1
1
1
1
1
1
Parts- 55
JACOBSEN FAIRWAY 250 SERIES: DH
SEAT SUSPENSION GRAMMER DS85H
Parts- 56
JACOBSEN FAIRWAY 250 SERIES: DH
ITEM
17-48
17-49
17-50
PART NO.
009054480
008173990
008174000
DESCRIPTION
MICROSWITCH
SCREW
CONNECTOR
* Not Illustrated
QTY.
REMARKS
1
2
1
Parts- 57
JACOBSEN FAIRWAY 250 SERIES: DH
ELECTRICS - INSTRUMENT PANEL
Parts- 58
JACOBSEN FAIRWAY 250 SERIES: DH
ITEM
PART NO.
DESCRIPTION
REMARKS
009050490
18-1
18-2
18-3
18-4
18-5
18-6
18-7
18-8
18-9
18-10
18-11
18-12
*
*
*
*
INCLUDES ALL ITEMS LISTED
WITH THE EXCEPTION OF
INSTRUMENT PANEL-HARNESS
MBG5127A
INSTRUMENT PANEL
008231870
TWIN PILOT LIGHT
178092-03
WATER TEMP GA #06347
178092-04
FUEL GAUGE #06339-01
2208066-01
CUTTER SWITCH
008295870
LENS-MOW ENGAGE
008295630
LENS-ENG PRE-HEAT
008295640
LENS-BATTERY CHARGE
008295650
LENS-PRE-HEAT
008295710
LENS-ENG O\HEAT
002952146
DOMED PLUG (7/8")
008295210
BLANKING PLUG
009055920
HARNESS-INSTRUMENT PANEL
MBE3961B.07 BEZEL - STEERING
009134160
GAITER (STEEL FRAME)
451126
SCRW PAN HD No.6 X 9.5
QTY.
* Not Illustrated
1
2
1
1
1
1
1
1
1
1
1
5
1
1
1
6
Parts- 59
JACOBSEN FAIRWAY 250 SERIES: DH
ELECTRICS - VARIOUS COMPONENTS
10
3
11
6
12
2
5
9
4
14
8
1
13
15
7
Parts- 60
JACOBSEN FAIRWAY 250 SERIES: DH
ITEM
*
*
*
*
*
18A-1
18A-2
18A-3
18A-4
18A-5
18A-6
*
*
*
18A-7
*
*
18A-8
18A-9
*
18A-10
18A-11
*
18A-12
*
*
18A-13
*
*
18A-14
18A-15
*
PART NO.
4118646
178083
148164
009055750
008220920
W148270
008244640
008109660
W038383
W38382
W128037
008238340
450149
450376
4139551
009055750
4116694
2208099
2208083
008233156
008233164
008233180
008233203
008238350
450529
450376
008244670
450149
450377
38665
48524
4175160
DESCRIPTION
MAIN HARNESS
CABLE - BATTERY NEGATIVE
CABLE - BATTERY POSITIVE
HARNESS - FUEL PUMP
SPLICES (AMP 34318)
SENDER -TEMP
SEAT SWITCH DELAY
HOURMETER LCD 2 TERMINAL
SWITCH N/C
SWITCH N/O
RELAY
RELAY BLOCK
SCREW HEX - M5 X 12
NUT NYLOC M5
INSULATION BOOT
WIRE-JUMPER (FUEL PUMP)
ADDITIONAL HARNESS
FOOT SWITCH
TEMPERATURE SWITCH 80C
FUSE 5 AMP
FUSE 10 AMP
FUSE 20 AMP
FUSE 30 AMP
FUSE CARRIAGE
SCREW-PAN M5 X 20
NUT NYLOC M5
LAMP TIMER
SCREW-HEX M6 X 12
NUT NYLOC M6
SOLENOID
CIRCUIT BREAKER 40AMP
Red Insulation Boot
* Not Illustrated
QTY.
1
1
1
1
2
1
1
1
2
1
3
4
2
2
1
1
1
1
1
1
2
1
1
1
2
2
1
1
1
1
1
1
REMARKS
HARDWARE FOR RELAY BLOCK
HARDWARE FOR FUSES
HARDWARE FOR LAMP TIMER
Parts- 61
JACOBSEN FAIRWAY 250 SERIES: DH
HYDRAULIC VALVE MOUNTING
Parts- 62
JACOBSEN FAIRWAY 250 SERIES: DH
19-1
19-2
19-3
19-4
19-5
19-6
19-7
*
19-8
19-9
19-10
19-11
19-12
19-13
19-15
19-16
19-17
19-18
19-20
19-21
19-22
19-23
19-24
19-25
*
*
*
19-25
001190034
2202091.07
2208038
W178025
450377
450389
2208046
64044-17
450005
450191
450390
450378
2198235
450392
450214
2208146
450412
450214
450371
2202112.07
2202114.07
2208028
2202115.07
2208144
148023-01
148023-02
148023-03
4171203
4171203-01
19-26 450120816
19-27 003802027
19-28 2206026A.0.7
19-28A 590002574
19-29 W068156A
19-30 450001
19-31 2208047
19-31 4212460
BLT-WLF 5/16-18 X 3/4
BRKT-FILTER
FILTER HEAD-SPIN ON
FILTER-SPIN ON
LOCKNUT NYLOC M6
WASHER-M6
VALVE BLCK-BACK PRESS
SCREW-SET FOR BACK PRESS
HEX BOLT M6-1 .0 X 50
BOLT HEX M8 X 20
WASHER-M8
LOCKNUT NYLOC M8
VALVE-DECK
WASHER-M10
SCREW-HEX M10 X 25
CYLINDER DRIVE VALVE
LOCKWASHER
BOLT M1O X 25
NUTSERT-M10
BRKT-HYD FITTING
BRKT-RETURN VALVE LH
MANIFOLD-RETURN
BRKT-RETURN VALVE RH
LIFT VALVE (DANFOSS)
• SEAL KIT
• DETENT KIT
• PILOT CHECK KIT
LIFT VALVE (EATON)
• SEAL KIT
NUT-JAM 3/8-16
MASTER LINK #50 CHAIN
WLDMT-LIFT HANDLE
OILITE BUSH 1/2" X 5/8" X 5/8"
HANDLE KNOB, BLACK
BOLT M6 X 30
CYLINDER CONTROL VALVE
CYLINDER CONTROL VALVE
3
1
1
1
6
10
1
1
4
2
4
4
1
4
2
1
2
2
1
1
1
1
1
1
1
1
1
1
1
1
1
1
2
1
3
1
1
*
*
19-32
19-33
19-34
19-35
CYLINDER CONT VALVE - SPACER
BRACKET BACKLAP SWITCH
NUT-M6 NYLOC
SPRING-COMPRESSION
MANIFOLD-LIFT
SCREW-HEX M8 X 40
1
1
3
2
1
2
Parts- 63
4210960
4213780
450377
2208085
2208051
450195
* Not Illustrated
DANFOSS
ROQUET (From S/N: DH000589,
CG200625, CH000629).
USE WITH ROQUET VALVE ONLY
USE WITH ROQUET VALVE ONLY
JACOBSEN FAIRWAY 250 SERIES: DH
HYDRAULIC VALVE MOUNTING
Parts- 64
JACOBSEN FAIRWAY 250 SERIES: DH
ITEM
PART NO.
19-36
19-39
19-45
*
19-46
19-47
19-48
19-49
19-50
19-51
19-52
19-53
2202211
450390
2208191
2208191-01
MBG1574
MBF1611.07
450026
450390
450378
450214
450391
450379
DESCRIPTION
STOP-BACK PRESSURE
WASHER-M8
VALVE-4WD
• SEAL KIT
PLATE-STIFFENER
4WD VALVE BRACKET
BOLT-HEX M8 X 90
WASHER M8
NUT M8 NYLOC
SCREW-HEX M10 X 25
WASHER M10
NUT M10 NYLOC
* Not Illustrated
QTY.
REMARKS
1
2
1
1
2
1
2
4
2
2
2
2
Parts- 65
JACOBSEN FAIRWAY 250 SERIES: DH
HYDRAULIC TRACTION CIRCUIT
Parts- 66
JACOBSEN FAIRWAY 250 SERIES: DH
ITEM
PART NO.
17-1
17-2
17-3
17-4
17-5
17-6
17-7
17-8
17-9
17-10
17-11
17-12
17-13
17-14
17-15
17-17
17-18
17-22
17-23
17-24
17-25
17-26
17-27
17-28
17-29
17-30
17-31
17-32
17-33
17-34
17-35
17-36
17-37
17-38
17-39
17-40
17-41
17-42
17-43
17-44
17-45
17-45
17-46
A800638
2208038
W178025
158006-12
A910032
A912171
108094-01
W158058-03
A259060
A799613
W158006-08
2208191
W158007-05
A799723
A799724
W158006-07
W148141-07
W158006-07
A251510
A799616
A251510
W158006-07
A799612
W158007-05
008007150
A799127
W69056-01
A799610
A799611
2692226-01
A259061
W158007-01
A799628
W178079
2208028
W69057-01
W158006-11
A259077
108092-11
108094-01
A244900
A249898
W158007-03
DESCRIPTION
PUMP (TRACTION)
FILTER HEAD
FILTER CANISTER
MALE CONNECTOR - 1 7/8 UNF
MANIFOLD - INLET
SUCTION HOSE
HOSE CLAMP
90° MALE ELBOW WITH HOSET
90° ELBOW WITH TEST PORT
HYDRAULIC HOSE ASSEMBLY
MALE CONNECTOR 1 1/16 UNF
VALVE BLOCK - TRANSMISSION
90° MALE ELBOW 7/8 UNF
HYDRAULIC HOSE ASSEMBLY
HYDRAULIC HOSE ASSEMBLY
MALE CONNECTOR 7/8 UNF
WHEEL MOTOR
MALE CONNECTOR 7/8 UNF
MALE CONNECTOR 9/16 UNF
HYDRAULIC HOSE ASSEMBLY
MALE CONNECTOR 9/16 UNF
MALE CONNECTOR 7/8 UNF
HYDRAULIC HOSE ASSEMBLY
90° MALE ELBOW 7/8 UNF
WHEEL MOTORMJ29
HYDRAULIC HOSE ASSEMBLY
BULKHEAD RUN TEE ORFS
HYDRAULIC HOSE ASSEMBLY
HYDRAULIC HOSE ASSEMBLY
HYDRAULIC HOSE ASSEMBLY
90° ELBOW WITH TEST PORT
90° MALE ELBOW 11/16 ORFS
HYDRAULIC HOSE ASSEMBLY
TEST FITTING
MANIFOLD - RETURN
SWIVEL NUT BRANCH TEE 11/16
MALE CONNECTOR 1 1/16 UNF
90° SWIVEL NUT ELBOW 1 ORFS
HOSE - SAE 100 R3
HOSE CLAMP
TEST PORT
HEXAGON PLUG 1 1/16 SAE
90° MALE ELBOW 7/8 UNF
* Not Illustrated
QTY.
REMARKS
1
1
1
1
1
1
4
1
1
1
1
1
3
2
2
4
2
1
1
1
1
2
1
4
2
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
Parts- 67
JACOBSEN FAIRWAY 250 SERIES: DH
HYDRAULIC TRACTION CIRCUIT
Parts- 68
JACOBSEN FAIRWAY 250 SERIES: DH
ITEM
PART NO.
17-47
17-48
17-49
17-50
17-51
17-52
2692222-01
W158006-03
2692215-18
2208041
A249351
A912172
DESCRIPTION
HYDRAULIC HOSE ASSEMBLY
MALE CONNECTOR 7/8 UNF
HYDRAULIC HOSE ASSEMBLY
TANDEM PUMP - FAIRWAY 250
MALE CONNECTOR WITH TAIL
SUCTION HOSE
* Not Illustrated
QTY.
REMARKS
1
1
1
1
1
1
Parts- 69
JACOBSEN FAIRWAY 250 SERIES: DH
HYDRAULIC CUTTINGS / STEERING / LIFT CIRCUIT
Parts- 70
JACOBSEN FAIRWAY 250 SERIES: DH
ITEM
PART NO.
18-1
18-2
18-3
18-4
18-5
18-6
18-7
18-8
18-9
18-10
18-11
18-12
18-13
18-13
*
*
18-14
18-15
18-16
18-17
*
18-18
*
18-19
18-20
18-21
18-22
18-23
18-24
18-25
18-26
18-27
18-28
18-29
18-30
18-31
18-32
18-33
18-34
18-35
18-36
18-37
18-38
18-39
2208031
2692233-01
48396
158058-08
2208038
W178025
2692222-01
2208146
A244905
W158006-05
2692219-02
W158007-03
2208047
4212460
4192320
002590190
W158006-05
A799476
W158007-03
008006820
A809615
008006810
A809615
W158007-03
A799475
A799477
A799627
A799625
A799626
W158006-01
W158007-01
A799558
A799118
A799114
A799622
A799621
2208028
W69057-01
2692214-13
2208142
2692215-18
A799620
W69055-01
2692217-03
DESCRIPTION
HYDRAULIC TANK
HOSE
HOSE CLAMP 2"
90° MALE ELBOW
FILTER HEAD
FILTER CANISTER
HOSE
VALVE, REEL DRIVE
TEST POINT
MALE CONNECTOR 3/4 UNF
HOSE
90° MALE ELBOW 7/8 UNF
VALVE, REEL DRIVE, FWD/REV
VALVE, REEL DRIVE, FWD/REV
90 FTG M/M 1/2" BSP X 13/16" ORF
FTG-STR M/M 1/2"BSP X 13/16" ORF
MALE CONNECTOR 3/4 UNF
HYDRAULIC HOSE ASSEMBLY
90° MALE ELBOW 7/8 UNF
HYDRAULIC MOTOR
• SEAL KIT
HYDRAULIC MOTOR
• SEAL KIT
90° MALE ELBOW 7/8 UNF
HYDRAULIC HOSE ASSEMBLY
HYDRAULIC HOSE ASSEMBLY
HYDRAULIC HOSE ASSEMBLY
HYDRAULIC HOSE ASSEMBLY
HYDRAULIC HOSE ASSEMBLY
MALE CONNECTOR 9/16 UNF
90° MALE ELBOW 11/16 ORFS
HYDRAULIC HOSE ASSEMBLY
HYDRAULIC HOSE ASSEMBLY
HYDRAULIC HOSE ASSEMBLY
HYDRAULIC HOSE ASSEMBLY
HYDRAULIC HOSE ASSEMBLY
MANIFOLD, RETURN
SWIVEL NUT BRANCH TEE 11/16
HYDRAULIC HOSE ASSEMBLY
STEERING UNIT
HYDRAULIC HOSE ASSEMBLY
HYDRAULIC HOSE ASSEMBLY
90° BULKHEAD ELBOW 11/16
HYDRAULIC HOSE ASSEMBLY
* Not Illustrated
QTY.
1
1
AR
1
1
1
1
1
1
2
1
2
1
1
2
2
2
1
9
4
1
1
1
1
1
1
1
1
1
4
1
1
1
1
1
1
1
1
1
1
1
2
2
2
REMARKS
DANFOSS
ROQUET
USE WITH ROQUET VALVE
USE WITH ROQUET VALVE
Parts- 71
JACOBSEN FAIRWAY 250 SERIES: DH
HYDRAULIC CUTTINGS / STEERING / LIFT CIRCUIT
Parts- 72
JACOBSEN FAIRWAY 250 SERIES: DH
ITEM
PART NO.
18-40
18-41
18-42
18-43
18-44
18-45
18-45
18-46
18-47
18-48
18-49
18-50
18-50
18-51
18-52
18-53
18-54
18-55
18-56
18-57
18-58
*
18-59
18-60
*
18-61
18-62
18-63
18-64
18-65
18-66
18-67
18-68
18-69
18-70
18-71
18-72
18-73
18-74
18-74
*
*
18-75
198040
W158007-01
W158006-01
2692215-17
W158006-05
2208144
4171203
2208068
2208046
2692219-01
W158007-01
69068-01
W69068-05
W158061-01
2692216-01
W158006-01
2208051
A244905
W158007-01
A799115
2208151
A230101
W158007-01
2208152
A230101
W15006-01
A799117
007991150
A799618
A799618
A799113
A799120
A799617
2692222-02
158065-03
A799628
W158056-01
2692223-03
2208050
4211162
4211260
002498480
69059-05
DESCRIPTION
STEERING RAM
90° MALE ELBOW 11/16 ORFS
MALE CONNECTOR 9/16 UNF
HYDRAULIC HOSE ASSEMBLY
MALE CONNECTOR 3/4 UNF
VALVE - LIFT (DANFOSS)
VALVE - LIFT (EATON)
TUBE LIFT VALVE
VALVE, REEL SPEED
HYDRAULIC HOSE ASSEMBLY
90° MALE ELBOW 11/16 ORFS
ORIFICE 0.054
ORIFICE 0.089"
O RING 0.364ID x 0.07 SECT
HYDRAULIC HOSE ASSEMBLY
MALE CONNECTOR 9/16 UNF
MANIFOLD
TEST POINT
90° MALE ELBOW 11/16 ORFS
HYDRAULIC HOSE ASSEMBLY
LIFT RAM
• SEAL KIT
90° MALE ELBOW 11/16 ORFS
LIFT RAM
• SEAL KIT
MALE CONNECTOR 9/16 UNF
HYDRAULIC HOSE ASSEMBLY
HYDRAULIC HOSE ASSEMBLY
HYDRAULIC HOSE ASSEMBLY
HYDRAULIC HOSE ASSEMBLY
HYDRAULIC HOSE ASSEMBLY
HYDRAULIC HOSE ASSEMBLY
HYDRAULIC HOSE ASSEMBLY
HYDRAULIC HOSE ASSEMBLY
FITTING ORS / NPTF
HYDRAULIC HOSE ASSEMBLY
MALE TEE 3/4 UNF 13/16 ORFS
HYDRAULIC HOSE ASSEMBLY
TUBE, OIL COOLER LH
TUBE, OIL COOLER LH
HYDRAULIC HOSE
FTG 13/16" ORF
CLAMP
QTY.
1
1
1
1
2
1
1
1
1
1
3
"2
1
3
1
1
1
1
3
2
2
1
6
3
1
3
1
1
1
1
2
1
2
1
1
1
1
1
1
1
1
1
AR
REMARKS
to serial no. xxxx
from serial no. xxxx
USE WITH 4196940 COOLER
Link between item 74 & 79
Parts- 73
JACOBSEN FAIRWAY 250 SERIES: DH
HYDRAULIC CUTTINGS / STEERING / LIFT CIRCUIT
Parts- 74
* Not Illustrated
JACOBSEN FAIRWAY 250 SERIES: DH
ITEM
PART NO.
18-76
18-77
18-78
18-79
18-79
18-80
18-81
18-82
18-82
18-*
18-*
18-*
18-*
18-*
108092-11
4115387
4116484
2203053
4211040
69059-02
2208069
006911620
4196940
48383
W158061-02
158006-13
158059-03
001992040
DESCRIPTION
HOSE SAE 100 R3 2
HYDRAULIC HOSE ASSEMBLY
90° MALE ELBOW WITH HOSET
TUBE, OIL COOLER RH
TUBE, OIL COOER RH
HOSE 100R3
TUBE REEL DRIVE
OIL COOLER (SETRAB)
OIL COOLER (THERMAL TRANSFER)
HOSE CLAMP 2 1/2
O-RING 0.489IDx0.07SECT
STR-CONNET UNF-ORFS
45 MALE UNF-ORFS 13/16-3/4
12mm CLIP
QTY.
"1
2
2
1
1
1
1
1
1
"6
3
1
1
1
REMARKS
USE WITH 4196940 COOLER
Parts- 75
JACOBSEN FAIRWAY 250 SERIES: DH
VALVE 4 WHEEL DRIVE
Parts- 76
JACOBSEN FAIRWAY 250 SERIES: DH
CV1
CV2
PD1
PLG6
DRF1
Parts- 77
2208191
178102-78
178102-01
178102-78
178102-01
178102-53
178102-54
178102-61
178102-63
178102-51
VALVE 4 WHEEL DRIVE
• VALVE
• • SEAL KIT
• VALVE
• • SEAL KIT
• VALVE
• • SEAL KIT
• PLUG
• • SEAL
• ORIFICE PLUG
* Not Illustrated
1
1
1
1
1
1
1
2
1
1
JACOBSEN FAIRWAY 250 SERIES: DH
SERVO TRANSMISSION PUMP - SAUER SUNDSTRAND
Parts- 78
JACOBSEN FAIRWAY 250 SERIES: DH
ITEM
A
104
105
118
126
127
131
132
133
155
160
201
202
401
501
930
1001
1103
1207
1210
1213
1214
1215
1216
1235
1401
1402
1403
1404
*
PART NO.
008006380
008008580
008008590
008008600
008008610
008008620
008008630
008008640
008008650
008008660
008008670
008008680
008008690
008008700
008008710
008008720
008008730
008008740
008008890
008008760
008008770
008008780
008008790
008008800
008008810
008008820
008008830
008008840
008008850
008008850
008008860
DESCRIPTION
TRANSMISSION PUMP
• CYLINDER BLOCK KIT
• SPRING
• POPPET
• NEEDLE BEARING
• PISTON
• SLIPPER RETAINER
• SHAFT BEARING
• CIRCLIP
• CIRCLIP
• CHARGE PUMP HOUSING
• CYLINDER BLOCK
• SWASHPLATE
• SWASHPLATE BEARING
• DRIVE SHAFT
• VALVE PLATE
• ADJUSTER SCREW
• BY-PASS VALVE
• RELIEF VALVE CARTRIDGE
• ROTARY SPOOL
• ADJUSTER SCREW
• LOCKNUT
• RETURN SPRING
• CONTROL LEVER
• CAM PLATE
• LOCKWASHER
• ORIFICE
• SLEEVE
• ORIFICE
• ORIFICE
• SEAL KIT
* Not Illustrated
QTY.
1
1
1
1
1
7
1
1
2
2
1
1
1
2
1
1
1
1
2
1
1
1
1
1
1
1
1
1
1
1
1
REMARKS
CHARGE RELIEF VALVE
CHARGE RELIEF VALVE
Parts- 79
JACOBSEN FAIRWAY 250 SERIES: DH
TANDEM PUMP (ULTRA)
Parts- 80
JACOBSEN FAIRWAY 250 SERIES: DH
ITEM
PART NO.
DESCRIPTION
QTY.
2208041
TANDEM PUMP
1
*
002300650
LIFT AND STEER PUMP
SEAL KIT
1
1
*
002300640
CUTTER PUMP
SEAL KIT
1
* Not Illustrated
REMARKS
Parts- 81
JACOBSEN FAIRWAY 250 SERIES: DH
CUTTING CYLINDER CONTROL VALVE (FWD / N / REV)
Parts- 82
JACOBSEN FAIRWAY 250 SERIES: DH
ITEM
A
1
*
PART NO.
2208047
008011620
008011820
DESCRIPTION
CONTROL VALVE
• SEAL KIT
HANDLE KIT
• 'S' HOOK
• PIN
• SPLIT PIN
• HANDLE
* Not Illustrated
QTY.
1
1
1
1
1
1
1
REMARKS
ALL THESE PARTS MUST BE
ORDERED AS PART OF THE
008011820 HANDLE KIT
Parts- 83
JACOBSEN FAIRWAY 250 SERIES: DH
HYDRAULIC STEER GEAR
Parts- 84
JACOBSEN FAIRWAY 250 SERIES: DH
ITEM
A
*
*
*
*
PART NO.
2208142
2208142-02
2208142-03
2208142-01
2208142-04
DESCRIPTION
HYDRAULIC STEER GEAR
• BEARING
• CAP
• SEAL KIT
• RELIEF VALVE
* Not Illustrated
QTY.
REMARKS
1
1
1
1
Parts- 85
JACOBSEN FAIRWAY 250 SERIES: DH
LIFT VALVE
Parts- 86
JACOBSEN FAIRWAY 250 SERIES: DH
ITEM
PART NO.
4171203
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
N/A
N/A
4171203-01
DESCRIPTION
QTY.
Valve, Lift
• Plunger
• Poppet Assembly
• Spacer
• Spool
• Seat Assembly
• Plug Assembly
• Plug Aswembly
• Bushing
• Spring
• Cap Assembly
• Detent Plunger
• Body
• Plug Assembly
• Spring
• O Ring
• Retaining Ring
• Spring
• Disc
• Plug Assembly
• Washer
• Wiper Seal
• Seal Kit
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
2
1
1
AR
1
1
1
AR
* Not Illustrated
REMARKS
Parts- 87
JACOBSEN FAIRWAY 250 SERIES: DH
LIFT VALVE
Parts- 88
JACOBSEN FAIRWAY 250 SERIES: DH
ITEM
1
2
*
PART NO.
2208144
148023-02
148023-03
148023-01
DESCRIPTION
VALVE LIFT
• DETENT ASSEMBLY
• RELIEF VALVE
• SEAL KIT
* Not Illustrated
QTY.
REMARKS
1
1
1
1
Parts- 89
JACOBSEN FAIRWAY 250 SERIES: DH
REEL DRIVE VALVE
Parts- 90
JACOBSEN FAIRWAY 250 SERIES: DH
ITEM
A
1
*
2
*
3
*
4
5
*
6
*
7
8
PART NO.
2208146
178102-37
178102-08
178102-12
1788102-05
178102-30
178102-40
178102-39
178102-16
178102-01
178102-18
178102-10
178102-55
178102-56
DESCRIPTION
REEL DRIVE VALVE
• NV10-21E-0-N
• • SEAL KIT
• RV10-22H-0-N-35/30
• • SEAL KIT
• EC10-30-0-N-80
• • SEAL KIT
• COIL (6359412)
• SV10-21W-0-N-00
• • SEAL KIT
• SAE PLUG (6118006)
• • SEAL KIT
• 5399000
• 5960110
* Not Illustrated
QTY.
REMARKS
1
1
1
1
1
1
1
1
1
1
6
1
3
1
Parts- 91
JACOBSEN FAIRWAY 250 SERIES: DH
VALVE, REEL SPEED
Parts- 92
JACOBSEN FAIRWAY 250 SERIES: DH
ITEM
1
2
3
4
3068
PART NO.
2208046
N/A
N/A
N/A
N/A
2208085
DESCRIPTION
VALVE
• KNOB
• CARTRIDGE
• O RING SEAL
• PORTED BODY
SPRING-SS COMPRESSION
* Not Illustrated
QTY.
1
1
1
1
1
1
REMARKS
NEEDLE VALVE
Parts- 93
JACOBSEN FAIRWAY 250 SERIES: DH
HYDRAULIC TRACTION MOTOR FRONT
Parts- 94
JACOBSEN FAIRWAY 250 SERIES: DH
ITEM
PART NO.
008007150
1
2
3
4
5
8
9
10
11
13
14
15
16
002301080
N/A
N/A
N/A
N/A
008007460
008007470
DESCRIPTION
FRONT WHEEL MOTOR MJ29
• HOUSING ASSY
• COUPLING SHAFT
• BOLT
• ROTOR SET
• SEAL KIT
• THRUST BEARING
• WEAR PLATE
• MANIFOLD
• COMMUTATOR ASSY
• END COVER ASSY
• KEY
• CASTLE NUT
• CIRCLIP
* Not Illustrated
QTY.
1
1
1
7
1
1
1
1
1
1
1
1
1
1
REMARKS
Torque 270Nm
Parts- 95
JACOBSEN FAIRWAY 250 SERIES: DH
HYDRAULIC TRACTION MOTOR REAR
Parts- 96
JACOBSEN FAIRWAY 250 SERIES: DH
ITEM
1
2
3
4
5
8
9
10
11
13
14
15
16
PART NO.
148141-07
008000500
008000460
N/A
N/A
N/A
N/A
008006270
008006260
DESCRIPTION
REAR WHEEL MOTOR ME
• HOUSING ASSY
• COUPLING SHAFT
• BOLT
• ROTOR SET
• SEAL KIT
• THRUST BEARING
• WEAR PLATE
• MANIFOLD
• COMMUTATOR ASSY
• END COVER ASSY
• KEY
• CASTLE NUT
• CIRCLIP
* Not Illustrated
QTY.
1
1
1
7
1
1
1
1
1
1
1
1
1
1
REMARKS
Torque 290Nm
Parts- 97
JACOBSEN FAIRWAY 250 SERIES: DH
DECALS
Parts- 98
JACOBSEN FAIRWAY 250 SERIES: DH
ITEM
1
4
8
9
10
11
12
14
16
19
20
26
27a
27b
28
29
30
31
32
33*
34*
PART NO.
IDL105
009034770
2000616
009034910
009094890
009033420
009114100
009034930
009039700
009034880
009114160
009039800
009034920
4124455
4124438
4124182
4124005
009114340
009034900
4118382
4146857
4153197
DESCRIPTION
DECAL KIT FAIRWAY 250
• DECAL - NOISE 105
• DECAL, ADJUST KNOBS
• DECAL - INSTRUCTION
• DECAL - BYSTANDER
• SET OF DECALS
• DECAL - BATTERY
• DECAL - HYD PRESS LEAK
• DECAL - PARKING BRAKE
• DECAL - FAN
• DECAL - SLOPE 15 DE
• DECAL - MOW DIRECTION
• DECAL - HOT
• DECAL - JACOBSEN FAIRWAY 250
• DECAL - JACOBSEN FAIRWAY 250
• DECAL - JACOBSEN
• DECAL - JACOBSEN
• DECAL - CAUTION DIESEL FUEL
• DECAL - ENGINE RUNNING
• DECAL - JOYSTICK DECAL
• DECAL-SEAT BELT ROPS
• DECAL-PRESSURE WASH
* Not Illustrated
QTY.
1
1
1
1
1
1
1
3
1
1
1
1
2
1
1
2
2
1
1
1
1
1
REMARKS
ENGINE COVER LH
ENGINE COVER RH
STEERING COLUMN
STEERING WHEEL CENTRE
Parts- 99
Ransomes Jacobsen Limited
West Road, Ransomes Europark, Ipswich,
England, IP3 9TT
English Company Registration No. 1070731
www.ransomesjacobsen.com
Jacobsen, A Textron Company
11108 Quality Drive, Charlotte,
NC 28273, USA
www.Jacobsen.com