Download SERVICE MANUAL - Philips Parts and Accessories

MDX-C800REC
SERVICE MANUAL
US Model
Canadian Model
Model Name Using Similar Mechanism
NEW
Mini Disc Mechanism Type
MG-715B-160
Optical Pick-up Name
KMS-263A
SPECIFICATIONS
AUDIO POWER SPECIFICATIONS
POWER OUTPUT AND TOTAL HARMONIC DISTORTION
19 watts per channel minimum continuous average power into
4 ohms, 4 channels driven from 20 Hz to 20 kHz with no more
than 1% total harmonic distortion.
Other Specifications
MD recoder section
Signal-to-noise ratio
92 dB
Frequency response
10 – 20,000 Hz
Wow and flutter
Below measurable limit
Laser Diode Properties
Material
GaAlAs
Wavelength
790 nm
Emission Duration
Continuous
Laser output power
Less than 5 mW*
* This output is the value measured at a distance
of 200 mm from the objective lens surface on the
Optical Pick-up Block.
General
Outputs
Inputs
Tone controls
Power requirements
Dimensions
Mounting dimensions
Mass
Supplied accessories
Tuner section
FM
Tuning range
Antenna terminal
Intermediate frequency
Usable sensitivity
Selectivity
Signal-to-noise ratio
87.5 – 107.9 MHz
External antenna connector
10.7 MHz/450 kHz
8 dBf
75 dB at 400 kHz
66 dB (stereo),
72 dB (mono)
Harmonic distortion at 1 kHz
0.6% (stereo),
0.3% (mono)
Separation
35 dB at 1 kHz
Frequency response
30 – 15,000 Hz
Audio outputs
Power antenna relay
control lead
Power amplifier control
lead
Telephone ATT control
lead
Digital input connector
BUS audio input connector
BUS control input connector
Bass ±9 dB at 100 Hz
Treble ±9 dB at 10 kHz
12 V DC car battery
(negative ground)
Approx. 178 × 50 × 184 mm
(7 1/8 × 2 × 7 1/4 in.)
(w/h/d)
Approx. 182 × 53 × 163 mm
(7 1/4 × 2 1/8 × 6 1/2 in.)
(w/h/d)
Approx. 1.5 kg (3 lb. 1 oz.)
Parts for installation and
connections (1 set)
Front panel case (1)
U.S. and foreign patents licensed from Dolby
laboratories Licensing Corporation.
Design and specifications are subject to change without
notice.
AM
Tuning range
Antenna terminal
Intermediate frequency
Sensitivity
530 – 1,710 kHz
External antenna connector
10.7 MHz/450 kHz
30 µV
FM/AM MINI DISC RECORDER
Power amplifier section
Outputs
Speaker outputs
(sure seal connectors)
Speaker impedance
4 – 8 ohms
Maximum power output 45 W × 4 (at 4 ohms)
1
HANDLING PRECAUTION FOR THE OVER WRITE HEAD
The over write head is susceptible to damage. When adjusting and
checking the over write head, it requires careful handling.
SERVICE NOTE
CAUTION
Use of controls or adjustments or performance of procedures other than those specified herein may result in hazardous radiation exposure.
Notes on Chip Component Replacement
• Never reuse a disconnected chip component.
• Notice that the minus side of a tantalum capacitor may be damaged by heat.
NOTES ON HANDLING THE OPTICAL PICK-UP BLOCK
OR BASE UNIT
The laser diode in the optical pick-up block may suffer electrostatic
breakdown because of the potential difference generated by the
charged electrostatic load, etc. on clothing and the human body.
During repair, pay attention to electrostatic breakdown and also use
the procedure in the printed matter which is included in the repair
parts.
The flexible board is easily damaged and should be handled with
care.
over write head
NOTES ON LASER DIODE EMISSION CHECK
The laser beam on this model is concentrated so as to be focused on
the disc reflective surface by the objective lens in the optical pickup block. Therefore, when checking the laser diode emission, observe from more than 30 cm away from the objective lens.
NOTES ON HANDLING THE OPTICAL PICK-UP BLOCK
(KMS-263A)
The laser diode in the optical pick-up block may suffer electrostatic
break-down easily. When handling it, perform soldering bridge to
the laser-tap on the flexible board. Also perform measures against
electrostatic break-down sufficiently before the operation. The flexible board is easily damaged and should be handled with care.
flexible board
pick-up
laser-tap
variable resistor
Never turn this
variable resistor.
SAFETY-RELATED COMPONENT WARNING!!
COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE
WITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN
THE PARTS LIST ARE CRITICAL TO SAFE OPERATION.
REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE
PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR
IN SUPPLEMENTS PUBLISHED BY SONY.
2
ATTENTION AU COMPOSANT AYANT RAPPORT
À LA SÉCURITÉ!!
LES COMPOSANTS IDENTIFIÉS PAR UNE MARQUE 0 SUR LES
DIAGRAMMES SCHÉMATIQUES ET LA LISTE DES PIÈCES
SONT CRITIQUES POUR LA SÉCURITÉ DE FONCTIONNEMENT.
NE REMPLACER CES COMPOSANTS QUE PAR DES PIÈCES
SONY DONT LES NUMÉROS SONT DONNÉS DANS CE MANUEL
OU DANS LES SUPPLÉMENTS PUBLIÉS PAR SONY.
TABLE OF CONTENTS
1. GENERAL
Location of controls ................................................................. 4
Getting Started ......................................................................... 4
Setting the clock ...................................................................... 4
MD player CD/MD unit .......................................................... 5
Recording on an MD ............................................................... 6
Editing an MD ......................................................................... 8
Radio ....................................................................................... 9
Other Functions ..................................................................... 10
TV/Video ............................................................................... 11
Connections ........................................................................... 13
4. EXPLODED VIEWS
4-1.
4-2.
4-3.
4-4.
4-5.
4-6.
Sub Panel Section .............................................................. 57
Front Panel Section ........................................................... 58
Chassis Section ................................................................. 59
MD Mechanism Section (1) .............................................. 60
MD Mechanism Section (2) .............................................. 61
MD Mechanism Section (3) .............................................. 62
5. ELECTRICAL PARTS LIST ........................................ 63
2. DISASSEMBLY
2-1. Sub Panel Assy .................................................................. 16
2-2. MD Mechanism Block ...................................................... 16
2-3. Main Board, Digital Board ................................................ 17
2-4. Heat Sink (REC) ............................................................... 17
2-5. MD Mechanism ................................................................. 18
2-6. Computer Board ................................................................ 18
2-7. Servo Board ....................................................................... 19
2-8. Tension Spring (B) ............................................................ 19
2-9. Chassis (L), (R) Assy ........................................................ 20
2-10. Loading Motor Assy .......................................................... 20
2-11. Sled Motor Assy ................................................................ 21
2-12. Sensor Board ..................................................................... 21
2-13. Spindle Motor Assy ........................................................... 22
2-14. Over Write Head ............................................................... 22
2-15. Optical Pick-up ................................................................. 23
3. DIAGRAMS
3-1. IC Pin Descriptions ........................................................... 24
3-2. Block Diagram –MD Section– .......................................... 30
3-3. Block Diagram –Tuner Section– ....................................... 31
3-4. Block Diagram –Display Section– .................................... 32
3-5. Circuit Boards Location .................................................... 33
3-6. Printed Wiring Board –Servo Section– ............................. 34
3-7. Schematic Diagram –Servo Section (1/3)– ....................... 36
3-8. Schematic Diagram –Servo Section (2/3)– ....................... 37
3-9. Schematic Diagram –Servo Section (3/3)– ....................... 38
3-10. Printed Wiring Board –Sensor Section– ........................... 39
3-11. Schematic Diagram –Sensor Section– .............................. 39
3-12. Printed Wiring Board –Computer Section– ...................... 40
3-13. Schematic Diagram –Computer Section– ......................... 41
3-14. Printed Wiring Boards –Main Section– ............................ 42
3-15. Schematic Diagram –Main Section (1/4)– ........................ 44
3-16. Schematic Diagram –Main Section (2/4)– ........................ 45
3-17. Schematic Diagram –Main Section (3/4)– ........................ 46
3-18. Schematic Diagram –Main Section (4/4)– ........................ 47
3-19. Printed Wiring Board –Relay Section– ............................. 48
3-20. Schematic Diagram –Relay Section– ................................ 49
3-21. Printed Wiring Board –Key Section– ................................ 50
3-22. Schematic Diagram –Key Section– ................................... 51
3
SECTION 1
GENERAL
4
This section is extracted
from instruction manual.
5
6
7
8
9
10
11
12
13
14
15
SECTION 2
DISASSEMBLY
Note : Follow the disassembly procedure in the numerical order given.
2-1. SUB PANEL ASSY
4 two claws
5 CN700
3 claw
2 PTT 2.6x6
6 sub panel assy
1 PTT 2.6x6
2-2. MD MECHANISM BLOCK
7 PTT 2.6x6
0 MD mechanism block
5 ground point screw
(PTT 2.6x6)
6 CONNECTION board
8 P 2x5
2 PTT 2.6x6
4 CN823
9 bracket (R) (MD)
1 PTT 2.6x6
3 CN100
16
2-3. MAIN BOARD, DIGITAL BOARD
5 MAIN board
3 ground point screw
(PTT 2.6x6)
8 DIGITAL board
4 ground point screws
(PTT 2.6x6)
6 CN821
2 PTT 2.6x10
7 PTT 2.6x10
1 PTT 2.6x10
2-4. HEAT SINK (REC)
6 heat sink (REC)
5 PTT 2.6x10
4 PTT 2.6x10
3 PTT 2.6x10
2 PTT 2.6x10
1 PTT 2.6x10
17
2-5. MD MECHANISM
2 P 2x3
1 P 2x3
9 CN561
3 shield case (U)
8 CN400
7 bracket (F) (MD)
0 MD mechanism
6 P 2x3
4 P 2x3
5 shield case (77)
2-6. COMPUTER BOARD
3 CN401
4 COMPUTER board
2 PS 2x4
1 PS 2x4
18
2-7. SERVO BOARD
1 PS 2x4
2 PS 2x4
6 SERVO board
5 CN440
3 CN510
4 CN520
2-8. TENSION SPRING (B)
1 tension spring (B)
2 tension spring (B)
19
2-9. CHASSIS (L), (R) ASSY
qa chassis (L) assy
0 damper (T)
8 chassis (R) assy
9 tension spring (F)
7 damper (T)
6 tension spring (F)
3 P 2x3
1 P 2x3
5 P 2x3
4 P 2x3
2 P 2x3
2-10. LOADING MOTOR ASSY
1 OWH flexible board
3 P 2x3
4 loading motor assy
5 lever (OPS)
2 CN552
20
2-11. SLED MOTOR ASSY
5 PS 2x4
2 wire
1 OWH flexible board
7 sled motor assy
6 CN551
3 P 1.7x2
4 spring (SL), leaf
2-12. SENSOR BOARD
1 Removal the solders
4 PS 2x4
3 CN551
2 CN552
5 PS 2x4
6
7 SENSOR board
claw
21
2-13. SPINDLE MOTOR ASSY
2 P 1.7x2
1 P 1.7x2
3 spindle motor assy
2-14. OVER WRITE HEAD
1 P 1.7x6
2 over write head (RF325-74A)
22
2-15. OPTICAL PICK-UP
4 K 2x3
2 OWH flexible board
6 main shaft
5 optical pick-up
3 K 2x3
1 OWH flexible board
23
SECTION 3
DIAGRAMS
3-1. IC PIN DESCRIPTIONS
• IC560 MB90574FPV-G-297-BND (MD CONTROL)
Pin No.
Pin Name
I/O
Pin Description
Write data transmission timing output to CXD2652AR, ON/OFF output of magnet
1
SCTX
O
head
2
LDON
O
Laser ON/OFF control output (“H”: Laser ON)
3
4
LOAD
EJECT
O
O
Loading motor control output (Loading direction)
Loading motor control output (Eject direction)
5
6
MDMON
LNKOFF
O
O
MD mechanism deck power supply control output
LINK OFF output to SONY BUS (“H”: LINK OFF, “L”: LINK ON)
7
8
UNIREQ
VCC
O
—
Request output to SONY BUS (“H”: Request ON) (Not used in this set.)
Power supply pin (+5 V)
9, 10
11
NC
FLASH-W
—
I
Not used (Open)
Select input for flash write (“L”: Flash write mode)
12
13
RXD/DSPSI
TXD/DSPSO
I
O
UART RXD data input
UART TXD data output
14
15
LIMIT-IN
EE CKO
I
O
Sled innermost track detection switch input (“L”: Innermost track)
Serial clock output for EEPROM
16
17
EE SIO
SENS IN
I/O
I
EEPROM data input/output
Disk photo sensor input (“H”: With desk)
18, 19
20
NC
SRDT
—
I
Not used (Open)
Data input from MD servo IC
21
22
SWDT
SCLK
O
O
Data output to MD servo IC
Clock output to MD servo IC
23, 24
25
26
NC
UNISI
UNISO
—
I
O
Not used (Open)
Data input from SONY BUS
Data output to SONY BUS
27
28
UNCKI
MOD
I
O
Clock input from SONY BUS
Laser modulation select signal output
29, 30
31
NC
FOPEN
—
I
Not used (Open)
Front panel open signal input
32
33
CLOSE OK
VSS
O
—
Front panel open/close request signal output
Ground pin
34
35
C
AGCHK
—
O
Power stabilization capacitor pin
Effect output when aging operation end of test mode
36
37
AGING
TFTON
O
O
Output of aging operation condition when test mode (Normally, open)
Output of drop running condition when test mode (Normally, open)
38
39
DVCC
DVSS
—
—
Power supply pin for D/A converter (+5 V)
Ground pin for D/A converter
40
41
ERR-PWM
ADER-PWM
O
O
PWM output of error rate (Normally, open)
PWM output of AD error (Normally, open)
42
43
AVCC
AVRH
—
—
Power supply pin for A/D converter (+5 V)
External reference power supply for A/D converter (Connect to AVCC in this set.)
44
45
AVRL
AVSS
—
—
External reference power supply for A/D converter (Connect to AVSS in this set.)
Ground pin for A/D converter
46
47
NC
ACNT
—
I
Not used (Open)
A/D input for designation on aging times of LOADING/EJECT
48
49
DOB-SEL
INIT
I
I
A/D input for designation on digital out bit number (Fixed at “H” in this set)
Initial input when reset
50, 51
52
TEST 0, 1
REF-SEL
I
I
Test pin (Normally, open)
Reference select input (Fixed at “L” in this set.)
53
54
NC
VCC
—
—
55
TSTMOD
I
24
Not used (Open)
Power supply pin (+5 V)
Test mode input (“L”: Test mode)
Pin No.
56
Pin Name
TSTSO
I/O
O
Pin Description
Data output for test mode display (Normally, open)
57
58 – 62
TSTCKO
NC
O
—
Clock output for test mode display (Normally, open)
Not used (Open)
63
64
VSS
NC
—
—
Ground pin
Not used (Open)
65
66
DACRST
DACCES
O
O
Reset output to DAC IC
Chip enable output to DAC (SUB)
67
68
DAC SO
DAC CKO
O
O
DAC control serial data output
DAC control serial clock output
69
70
DAC CEF
DAC CER
O
O
Chip enable output to DAC (FRONT)
Chip enable output to DAC (REAR)
71, 72
73
NC
XIA
—
—
Not used (Open)
Input for sub clock oscillation (Fixed at “H” in this set)
74
75
XOA
CC-XINT
—
I
Input for sub clock oscillation (Connect to ground pin in this set)
XINT interruption input from MD servo IC
76
77
BUS-ON
BU-IN
I
I
BUS ON input of SONY BUS
Power instantaneously cut off check port of system
78
79
SQ-SY
DISC-IN
I
I
SUBQ SYNC interruption input from MD servo IC
DISC-IN (cartridge in switch) sensor input of MD mechanism deck
80
81
A-ATT
DQ-SY
O
I
Audio attenuator output (“H”: ATT ON)
Subcord Q sync of DIGITAL IN U-bit CD format from MD servo IC
82
83
NC
EJECT IN
—
I
Not used (Open)
EJECT (MD) switch input
84
85
86
SORCE
LOCK
HSTX
I
O
—
Select signal input of signal input (analog/digital input) (Not used in this set)
Output of CLV lock condition when test mode (Normally, open)
Hardware standby input (Connect to SYSRST in this set)
87
88, 89
MD2
MD1, 0
—
—
CPU operation mode designation input (Connect to ground pin in this set)
CPU operation mode designation input (Fixed at “H” in this set)
90
91
RSTX
VSS
—
—
Reset input (Fixed at “H” in this set)
Ground pin
92
93
X0
X1
I
O
Main clock oscillation input (3.68 MHz)
Main clock oscillation output (3.68 MHz)
94
95, 96
VCC
NC
—
—
Power supply pin (+5 V)
Not used (Open)
97
98, 99
RAMBU
NC
I
—
RAM backup detection input
Not used (Open)
100
101
MD/REC-ON
RF-ON
O
O
Power control output for overlight head
Power control output for RF AMP
102
103
REC-P
PLAY-P
I
I
Detection signal input from REC position detection switch (“L”: REC position)
Detection signal input from PLAY position detection switch (“L”: PLAY position)
104
PROTECT
I
Recording prevention claw detection input from write protect detection switch
(“H”: Write Protect)
105
REFLECT
I
Desk reflectance detection input from reflect detection switch
(“H”: Low reflectance disk IN)
106
107
PACK-IN
NC
I
—
108
REC/PLAY
I
109
DFCTSEL
I
110
WRPWR
O
111
PREHEAT
O
(“L”: READ POWER, “H”: WRITE POWER)
Preheat control output (“H”: Preheat ON)
112
MDRST
O
Reset output to MD servo IC
PACK-IN (LOADING END SENSOR) sensor input of MD mechanism deck
Not used (Open)
Change select input on recording mechanism deck and playing mechanism deck
(“H”: REC, “L”: PLAY) (Fixed at “H” in this set)
Select input on used of DEFECT2 function (Not used in this set (Fixed at “H”))
Laser power select signal output to optical pick-up or CXD2652AR
25
Pin No.
113
Pin Name
MDLAT
I/O
O
114
115 – 118
SERVO-ON
MNT3 – 0
O
I
Power control output to MD servo IC
Monitor 3 – 0 input of CXD2652AR
119
120
VSS
SENS
—
I
Ground pin
Sens input from MD servo IC
26
Pin Description
Latch output to MD servo IC
• IC650 HD64F2357F (DISPLAY CONTROL)
Pin No.
Pin Name
I/O
1, 2
PG3, 4
O
Not used in this set (Open)
Pin Description
3
4
VSS
NC
—
—
Ground pin
Not used in this set (Open)
5
6–9
VCC
PC0 – 3
—
O
Power supply pin (+5 V)
Not used in this set (Open)
10
11 – 14
VSS
PC4 – 7
—
O
Ground pin
Not used in this set (Open)
15 – 18
19
PB0 – 3
VSS
O
—
Not used in this set (Open)
Ground pin
20 – 23
24
PB4 – 7
PA0
O
O
Not used in this set (Open)
Signal out select control output to the IC652 (BA3834F)
25
26
PA1
PA2
O
O
Signal out select control output to the IC652 (BA3834F)
Signal out select control output to the IC652 (BA3834F)
27
28
PA3
VSS
O
—
Signal out select control output to the IC652 (BA3834F)
Ground pin
29 – 32
33
PA4/IRQ4 – PA7/IRQ7
SP LAT
O
I
Not used in this set (Open)
Not used in this set (Open)
34
35, 36
P66/IRQ2
VSS
I
—
Not used in this set (Open)
Ground pin
37
38
P65/IRQ1
BUS ON
O
I
Not used in this set (Open)
SONY BUS on input “L”: Active
39
40
VCC
CD/MD
—
O
Power supply pin (+5 V)
Not used in this set (Open)
41 – 43
44
45
PE1 – 3
VSS
TIR IND
O
—
O
Not used in this set (Open)
Ground pin
Not used in this set (Open)
46, 47
48
PE 5, 6
MD LOCK
O
O
Not used in this set (Open)
Not used in this set (Open)
49
50
BU IN
LINK OFF
I
O
Backup power supply detection input
Link off output
51
52
PD2
ILL ON
O
O
Not used in this set (Open)
Illumination power supply control output
53
54, 55
VSS
NCO
—
O
Ground pin
Not used in this set (Open)
56
57
PD6
BOOT
O
I
Not used in this set (Open)
Display microcomputer write control input
58
59
VCC
NC
—
—
Power supply pin (+5 V)
Not used in this set (Open)
60
61
TX/LCDDATA
SP SI
O
I
LCD driver serial data output/Frash microcomputer write data output
DSP serial data input
62
63
RX/DOOR SW
SP SCK
I
I
Flash microcomputer write data input/Door detection input
Not used in this set (Open)
64
65
LCD CLK
VSS
O
—
LCD driver serial clock output
Ground pin
66
67, 68
LCD CEO
VSS
O
—
LCD chip enable signal output
Ground pin
69
70
LCDINH
LCDCE1
O
O
Not used in this set (Open)
LCD chip enable signal output
71
72 – 78
P63
P27 – 21
O
O
Not used in this set (Open)
Not used in this set (Open)
79
80
FL W
FWE (L)
O
O
Flash write control output
Flash write enable input
“H”: Back up
27
Pin No.
81
Pin Name
RES
I/O
I
82
83
NMI (H)
STBY (H)
I
I
84
85
VCC
XTAL
—
O
Power supply pin (+5 V)
Crystal oscillation output (18.432 MHz)
86
87
EXTAL
VSS
I
—
Crystal oscillation input (18.432 MHz)
Ground pin
88
89
PF7
VCC
O
—
Not used in this set (Open)
Power supply pin (+5 V)
90 – 96
97
PF6 – 0
UNI-SO
O
O
Not used in this set (Open)
SONY BUS system serial data output
98
99, 100
UNI-SI
VSS
I
—
SONY BUS system serial data input
Ground pin
101
102
UNI-SCK
P53/ADTRG
I
O
SONY BUS system serial clock input
Not used in this set (Open)
103
104
AVCC
VREF
—
—
Power supply pin (+5 V) of analog macro (D/A, A/D etc.)
A/D, D/A converter reference voltage pin (+5 V)
105
106 – 110
P40/AN0
P41/AN0 – P45/AN5
I
I
Peak hold voltage detection input from the IC652 (BA3834F)
Not used in this set (Connect to ground in this set)
111
112
P46/AN6/DA0
P47/AN7/DA1
I
I
Not used in this set (Connect to ground in this set)
Not used in this set (Connect to ground in this set)
113
114
AVSS
VSS
—
—
Ground pin
Ground pin
115 – 122
123 – 125
126 – 128
P17 – P10
MD0 – 2 (H)
PG0 – 2
O
I
O
Not used in this set (Open)
Operation mode setting input (Fixed at “H” in this set)
Not used in this set (Open)
28
Pin Description
System reset input
Non-maskable interruption input (Connect to pin rl (BU IN).)
Hardware standby input “H”: Not used
• IC700 MB90574PMT-G-259-BND (SYSTEM CONTROL)
Pin No.
Pin Name
I/O
Pin Description
1
TUN ON
O
Tuner power control output (TU +5.6 V)
Pin No.
Pin Name
I/O
59
60
MUTE
AMP ON
O
O
LINE level mute output
Power amplifier standby control output (to STNBY pin of power IC)
Pin Description
61
62
N.C.O
FLASH WHT
O
I
Not used in this set (Open)
Flash memory read mode detect input
63
64
VSS
RE IN0
—
I
Ground pin
Rotary encoder input 0
65
66
PWM
RE IN1
I
I
D/D converter oscillator frequency signal input
Rorary encoder input 1
67
68
MD BOOT
N.C.O
I
O
Flash write select input
Not used in this set (Open)
69
70
RAM BU
II DATA
I
I/O
RAM reset detection input
I2C BUS serial data input/output (SONY BUS interface to tuner, electron volume, RDS.)
71
72
II CLK
RC IN1
I/O
I
I2C BUS serial clock input/output (SONY BUS interface to tuner, electron volume, RDS.)
Shift input of rotary commander
73
74
X1A
X0A
I
O
Low speed oscillator connect pin (32,768 kHz)
75
76
SHIFT
KEYACK
O
I
D/D converter frequency change signal output
Key acknowledge input
77
78
BU IN
DAVN
I
I
Backup voltage detection input
Block synchronization detection input of RDS data
79
80
TEL ATT
TEST IN
I
I
Telephone (TEL) detection input
Test mode setting pin
81
DP BOOT
O
Display microcomputer frash write setting output
“L” is output when write of display microcomputer
82 – 84
85
N.C.O
NS MASK
O
O
Not used in this set (Open)
Noise mask output
2
3
SET UP
FM ON
O
O
Not used in this set (Open)
Not used in this set (Open)
4
5
AM ON
N.C.O
O
O
Not used in this set (Open)
Not used in this set (Open)
6
7
SYS RESET
BUS ON
O
O
SONY BUS system reset output (SONY BUS interface to CD, external control)
SONY BUS on control output (SONY BUS interface to CD, external control)
8
VCC
—
9
FLS PON
O
+5 V power supply pin
Flash drive power control output (ILL ON power supply)
10
EEDATA
O
“H” is output when flash read.
EEPROM data output
11
12
EECLK
DOOR SW/RXD
O
I
EEPROM CLK output
Door open/close detection input
13
14
TXD
N.C.O
O
O
Serial data output
Not used in this set (Open)
15
16
BEEP
AMP MUTE
O
O
Beep output
Power amplifier mute output
17 – 19
20
N.C.O
UNI SI
O
I
Not used in this set (Open)
SONY BUS serial data input (SONY BUS interface to CD, external control)
21
22
UNI SO
UNI CLK
O
I/O
23
24
N.C.O
SIRCS
O
I
Not used in this set (Open)
Remote commander (infrared rays reseiver) input
25 – 29
30
31
N.C.O
SW SHIFT
N.C.O
O
O
O
Not used in this set (Open)
Tuner switch shift output
Not used in this set (Open)
32
33
TUNER MUTE
VSS
O
—
Tuner mute control output (AM DET MUTE)
Ground pin
86
87
HSTX
MD2
I
I
Hardware standby input (This set connect to RSTX.)
Input for operation mode (This set connect to VSS.)
34
35
C
AD ON
—
O
Capacitance connect pin of power supply stabilization
Power supply control output for AD conversion
88
89
MD1
MD0
I
I
Input for operation mode (This set connect to VCC.)
Input for operation mode (This set connect to VCC.)
36
37
RDS ON
N.C.O
O
O
Power supply signal output to RDS (Not used in this set (Open))
Not used in this set (Open)
90
91
RSTX
VSS
I
—
Reset input
Ground pin
38
39
DVCC
DVSS
—
—
D/A converter VRER pin
D/A converter GND pin
92
93
X0
X1
O
I
High speed oscillator connect pin (3.6864 MHz)
40
41
POWER ON
N.C.O
O
O
System power supply control output
Not used in this set (Open)
94
95
VCC
N.C.O
—
O
+5 V power supply pin
Not used in this set (Open)
42
43
AVCC
AVRH
—
I
Analog power supply pin
A/D converter Vref (+) pin
96
97
PARKING
N.C.O
I
O
Parking brake detection input
Not used in this set (Open)
44
45
AVRL
AVSS
I
—
A/D converter Vref (–) pin
Analog ground pin
98
99
SHIN
N.C.O
O
O
Not used in this set (Open)
Not used in this set (Open)
46
47
KEY IN0
KEY IN1
I
I
Key signal input 0 (A/D analog input)
Key signal input 1 (A/D analog input)
100
101
ILL IN
NOSE SW
I
I
Illumination (ILL IN) detection input
Front panel attachment detection input
48
49
DSTSEL0
RC IN0
I
I
Initial setting input of destination
Key input of rotary commander (A/D analog input)
102
103
PACK IND
PD
O
O
Door indicator output
Codec power supply control output
50
51
QUALITY
FM AGC
I
I
Noise detection input (A/D analog input)
FM AGC detection input (A/D analog input)
104
105
SERVO-ON
ACC IN
I
I
Servo power supply control signal input from mechanism microcomputer
Accessory power supply (ACC) detect input
52
53
MPT
VSM
I
I
Multipath detection input (A/D analog input)
Signal meter detection input (A/D analog input)
106
107 – 118
SMUTE
N.C.O
O
O
Codec mute signal output “H”: mute
Not used in this set (Open)
54
55, 56
VCC
N.C.O
—
O
+5 V power supply pin
Not used in this set (Open)
119
120
VSS
LOW +B CHK
—
O
Ground pin
Low battery check output
57
58
E-VOL MOTE
N.C.O
O
O
Electron volume mute output
Not used in this set (Open)
“L”: close, “H”: open
SONY BUS serial data output (SONY BUS interface to CD, external control)
SONY BUS serial clock input/output (SONY BUS interface to CD, external control)
“L”: off, “H”: on
29
29
“L”: packing condition
“L”: on, “H”: off
“H”: on
MDX-C800REC
3-2. BLOCK DIAGRAM — MD SECTION —
LD
CONT
Q442
LD
CONT
Q444
PD
10 PD
M503
(SPINDLE)
M501
(SLED)
6 4F
IN
TRACKING
3F
3R
OUT
FOCUS
1F 19
1R 18
3F 14
3R 15
88
89
86
85
AUX
ADFG
OSCI 16
SE
TE
D0-D3
25 2R
4R 3
94 SPFD
2F 29
92 SFDR
2R 30
91 SRDR
PSB 16
10 XRST
OVER-WRITE
HEAD
ON/OFF
DRIVE
Q510,511
REC
DRIVE
IC510
XINT
DQSY
SRDT
MNT3
MNT2
MNT1
MNT0
REC
CONTROL
Q512
X300
22.5792MHz
14
12
11
9
8
4
3
2
1
D0-D3
MD CONTROL
IC560
FLASH W 11
X560
3.68MHz
92 XO
SCL 6
DAL 5
(SLOC)
(XBUSY)
(SHCK)
IC561
IC562
(SFOK)
:MD PB
SERVO 3V
15 CKO
16 SIO
75
81
78
120
20
115
116
117
118
RI 2
BATT
CC XINT
DQSY
B/U 5V
SQSY
SENS
SRDT
MNT3
MNT2
MNT1
MNT0
113 MD LAT
22 SCLK
21 SWDT
LDON
MOD
MD RST
SCTX
FIN 4
4 EJECT
7 OUT2
RIN 5
3 LOAD
RESET
IC563
97 RAM BU
30
IN B 14
OUT1 7
SOFT
START
Q561,562
5V
POWER
CONT
Q831,832
MD12V
FOPEN 31
RXD/DSPSI 12
TXD/DSPSO 13
SI
SO
CKI
HS TX
BU IN
BUS ON
UNISI
UNISO
UNICK
SYSRES
BUIN
BUS ON
IC564
SW550-555
LIMIT IN 14
PROTECT 104
DISC IN
PACK IN
REC P
PLAY P
1
106
102
103
3
TXD
3V
REG
IC802
SERVO 3V
SERVO 5V
ON/OFF
DRIVE
Q827
INA 3
MD/REC ON 100
RXD
25
26
27
86
77
76
WRPWR
1 OUT1
9 VCC
MDM 5
ON
BATT
TUNER
SECTION
(Page 31)
ON/OFF
DRIVE
Q830
OUT2 10
POWER
CONT
Q825
LOADING MOTOT DRIVE
IC521
101 RF ON
30
SERVO ON
DC/DC CONV.CONT.
IC801
REFLECT 105
B/U 5V
2
MD ATT
A-ATT 80
93 XI
EEPROM
IC402
3V
TO
5V
M502
(LOADING)
• Signal path
04
SHIFT
CONTROL
Q826
SHIFT 75
SERVO ON 104
MD BOOT 67
2
28
112
1
110
: MD REC
PWM 65
65 XDAC RST
XLAT 7
SCLK 6
SWDT 5
15 TX
13 SRECP
SOFT
START
Q440,441
106 SMUTE
103 PD
Q300
A00-A11
4 WE
5 RAS
20 OE
21 CAS
XWE 45
XRAS 44
XOE 41
XCAS 42
100 EFMO
RF 3V
SYSTEM CONTROL
IC700(1/3)
SERVO 114
ON
SQSY
SENS
MOD
DRIVE
IC442
Q445-447
J800
(DIGITAL IN)
TRDR
8 4R
27 2F
OSC
IC301
DRAM
IC401
FFDR
FRDR
TFDR
93 SPRD
R-CH
SMUTE 16
PD 24
DEMO 17
PULSE
SHAPE
IC403
DIN 21
FOCONT
XLRF
CKRF
DTRF
APCREF
4F 4
1
TUNER
SECTION
(Page 31)
19
FE
PICK-UP DRIVE
IC520
1F
1R
R-CH
ADL
4
2
A/D
CONV.
MCKI
65
66
78
73
74
79
80
81
82
83
FE 34
AUX 33
ADFG 32
SE 28
TE 26
FOCNT 20
XLAT 18
SCLK 17
SWDT 16
APCREF 12
11 APC
21
23
12
10
I/O
I/F
DAL
26
27
D/A
CONV.
75 AUX2
6-11
14-19
POWER
CONTRIL
Q443
LD
E
I
ABCD
SDTI
14
12 LRCK
13 SCLK
15
SDTO
24
25
26
23
2,3
22,23
E
D
A
DADT
LRCK
XBCK
ADDT
PEAK
BOTM
A00-A11
29-39
43
7
4
8
1
PEAK
HOLD
Q400
RF
UNI
2 J
J
55
62
63
64
DAC/ADC
IC300
46-49
C B
A D
I
RF 38
PEAK 37
BOTM 36
ABCD 35
9 F
6 C
5 B
F
DSSP & DSP
IC400
EE
RF AMP
IC440
OPTICAL PICK-UP
KMS-263A
DISPLAY
SECTION
(Page 32)
4
DISPLAY
SECTION
(Page 32)
POWER
CONT
Q828,829
REC 5V
MDX-C800REC
3-3. BLOCK DIAGRAM — TUNER SECTION —
CNP101
ADL
1
R-CH
MD
SECTION
(Page 30)
TUNER UNIT
TU1
2 FM
ANT
DAL
R-CH
R-CH
MUTE
Q1
MPX 10
1 SEIL
2 SEIR
13 MPX
RL 29
RR 27
AM IF 19
12 AMIF
MUTE
Q2
AM
DET 8
TUNER
MUTE
Q3
R-CH
SSL 24
SSR 23
FL 30
FR 28
15 MPIN
AM
1 ANT
-6
3 SE 3L
5 SE 3R
SMETER 14
11
20
21
18
R-CH
SWL 26
MUTE
Q102
R-CH
R-CH
POWER AMP
IC104
S/P SIG
DISPLAY
SECTION (Page 32)
XO 92
BEEP 15
IIC
LOW+B
CHK 120
70 DATA
71 CLK
FM AGC 4
SW SHIFT 7
51 FM AGC
30 SW SHIFT
MUTE STBY
22
4
4 STB
10 DATA
11 CLK
POWER
CONT
Q823,824
AMP+B 6
2 TU ON
3 TU ON
BZ800
BATT
7 VCC
10 TU 5V
11 TU 8V
TU5V
TU8V
BATT
CHECK
IC703
FR+
4
FR11
RR+
12
RR16
6
5
ANT +B 8
COM8V 9
BU5V 5
BATT
AMP-R
ANT-R
COM8V
BATT
REG
Q821
BU5V
BATT
15
ILL 100
AGC 105
PARKING 96
POWER ON 40
XOA 74
RL-
POWER SUPPLY
IC280
X701
3.686MHz
BEEP
DRIVE
Q700
FL-
3
R-CH
TEL
ATT
Q822
TEL ATT 79
DAT 17
CKL 18
10
19
BATT
TU ON 1
RDS 9
FL+
RL+
15
MUTE 59
AMP MUTE 16
AMP ON 60
XI 93
CKL 13
17
MUTE
CONT
Q703-705
MD ATT
53 VSM
1
7
9
MD
SERVO ON
SECTION
(Page 30)
SYSTEM CONTROL
IC700(2/3)
2
11
MUTE
Q103
2
SM
R
REAR
AUDIO
OUT
CNP820
9
MUTE
Q103
R-CH
SCL
DAT 12
L
-4
AM
SDL
32 TU MUTE
R
FRONT
AUDIO
OUT
-3
5
57 EV MUTE
EEP
J1
(ANTENNA)
ELECTRONIC VOLUME
IC102
IIC
-2
CNP101
-5
L
MUTE
Q102
EEP
L
BUS
AUDIO
IN
R
-1
ACC
CHECK
Q701
7
ACC
14
13
X700
32.768kHz
XIA 73
BU5V
POWER
CONT
Q651
04
31
31
S/P5V
COM8V
5V REG
IC284
ILL
D5V
ATT
PARKING
MDX-C800REC
3-4. BLOCK DIAGRAM — DISPLAY SECTION —
TUNER
SECTION
(Page 31)
S/P SIG
8 A IN
DISPLAY CONTROL
IC650
A OUT 17
SEL 14
A 10
B 11
C 12
105
24
25
26
27
X650
18.432MHz
AN0
PA0
PA1
PA2
PA3
LINK OFF 50
SO 97
SCK 101
SI 98
BUS ON 38
BU IN 49
NMI 82
RES 81
UNI
SPECTRUM ANALYZER
IC652
5
86 EXTAL
DIMMER
CONT
Q950,952
COLOR
SEL
Q942,943
84 GREEN
85 AAMBER
BUF
IC651
BATT
87 DIMMER
REG
Q835,836
CEO 98
CL 99
DI 100
66 CEO
64 CLK
70 CEI
RX/
DOOR SW 62
12 DOOR SW/
RXD
BU IN 77
10
TX/ 60
LCD DATA
13 TXD
SYS RST 6
13
2
BUS ON 7
12
1
SI 20
8
SO 21
9
85 GREEN
86 RED
72 RC IN1
49 RC IN0
J700
(REMOTE IN)
CLK 22
TEST
TERMINAL
FXD
BOOT
LCD10V
4
62 FLASH WHT
LCD10V
3
LED
DRIVE
Q833,834
MD SECTION
(Page 30)
RXD
7
4
UNI SO
UNI SI
UNI CK
(Page 30)
SIRCS 24
101 NOSE SW
ROTARY
ENCODER
RE900
32
4
102 PACK IND
S700
(NOSE SW)
TXD
3
2
1
MD SECTION
3
LED800
04
76 KEY AVK
BUS IN
KEY
ACTIVE
Q702
BU5V
1
6
5
4
BUFFER
Q782,783
BUS ON
POWER
CONT
Q702
6
11
SYS RST
TXD
ACT+B
2
CN780
8
46 KEY IN0
47 KEY IN1
35 AD ON
CN802
BATT
3
(BUS CONTROL IN)
KEY IN
MATRIX
KEY
BOARD
LOW
BATT
DET
Q780
UNI
LSW900-911
921-930
CEI 98
CL 99
DI 100
S800
(RESET)
BUS INTERFACE
IC780
RSTX 90
HSTX 86
LCD DRIVE
IC980
LED921-923
RESET
IC701
SYSTEM CONTROL
IC700(3/3)
9 FLS PON
81 DP BOOT
LOQUID CRYSTAL
DISPLAY
LCD900
LED
DRIVE
Q944,945
LCD10V
ILL ON 52
BOOT 57
LCD
LSW900-911,
924-930
BATT
85 XTAL
LCD DRIVE
IC970
LED951-956
BATT
CHECK
Q781
64 RE IN0
66 RE IN1
32
RAMBU 69
SRAM
RESET
IC702
IR
RECEIVE
IC960
Q784
BU5V
3-5. CIRCUIT BOARDS LOCATION
THIS NOTE IS COMMON FOR PRINTED WIRING
BOARDS AND SCHEMATIC DIAGRAMS.
(In addition to this, the necessary note is
printed in each block.)
COMPUTER board
For schematic diagrams
• All capacitors are in µF unless otherwise noted. pF: µµF
50 WV or less are not indicated except for electrolytics
and tantalums.
• All resistors are in Ω and 1/4 W or less unless otherwise
specified.
•
%
: indicates tolerance.
f
•
: internal component.
• C : panel designation.
DIGITAL board
SENSOR board
CONNECTION board
RELAY board
• Waveforms (MODE:PLAY)
(SERVO/COMPUTER BLOCK)
1
Approx.
0.5Vp-p
IC440
tuner unit
(TU1)
MAIN board
KEY board
(TE)
2
Approx.
0.3Vp-p
Note: The components identified by mark 0 or dotted line
with mark 0 are critical for safety.
Replace only with part number specified.
• U : B+ Line.
• Power voltage is dc 14.4V and fed with regulated dc power
supply from ACC and BATT cords.
• Voltages are taken with a VOM (Input impedance 10 MΩ).
Voltage variations may be noted due to normal production tolerances.
• Waveforms are taken with a oscilloscope.
Voltage variations may be noted due to normal production tolerances.
• Circled numbers refer to waveforms.
• Signal path.
F : FM
f : AM
J : MD
wh
IC440
ef
(FE)
3
1.4Vp-p
IC440
ek
(RF)
4
4.8Vp-p
24µsec
IC400
SERVO board
wg
(LRCK)
5
For printed wiring boards
• X : parts extracted from the component side.
• Y : parts extracted from the conductor side.
a
•
: Through hole.
f
: internal component.
•
• b : Pattern from the side which enables seeing.
(The other layer’s patterns are not indicated.)
Caution:
Pattern face side:
(Side B)
Parts face side:
(Side A)
4.8Vp-p
0.35µsec
IC400
wh
(XBCK)
6
Parts on the pattern face side seen from the
pattern face are indicated.
Parts on the parts face side seen from the
parts face are indicated.
4.4Vp-p
2.8µsec
IC520
ea
(CAPA+)
7
4.4Vp-p
2.8µsec
IC520
es
(CAPA–)
8
3.4Vp-p
3.68MHz
IC560
33
33
os
(XO)
MDX-C800REC
3-6. PRINTED WIRING BOARD — SERVO SECTION —
• Semiconductor
Location
R517
CN510
1
1
IC510
11
8
20
C516
R516
SERVO BOARD (SIDE A)
D511
Q511
(Page 39)
B
F-4
F-6
F-6
E-1
E-1
F-2
E-1
E-1
F-1
B-6
B-6
B-7
C-4
R512 R513
S
SENSOR BOARD
CN550
D510
S
Q512
C517
Q510
6
1
32
D520
2
C414
RB402
IC400
MAIN BOARD
CN100
(Page 42)
R487 R463
R462 R464 R465 75
76
100
C425
1
D440
1
R440
4
34
D-GND
Q440
R444
R443
R442
Q441
L440
C444
3
34
3
RB400
C441
C440
C447
R454
R459 R460
25
R441
C446
R458 R457
25 C453
24 C452
R400
26
CN400
C454
12
13
C418 R402
R466
37
36
R447
C443
R446
R448 48
R449 1
IC440
2
1
35
R401
C415 50
51
R467
C460
R404
04
1
COMPUTER BOARD
CN560
24
L443
L442
R461
C469
21
5
(Page 40)
C528
R483
R482
Q447
1 IC442
2
51
12
IC401
C450 R456 R455
FB443
5
3
C474
F
C471 C473
R484
R486
R485
13
C458
R470
C459
R469
C457
R521
C524
R472
R471
R476
R474
Q446
C470 Q445
1
Q520
17
1
Q443
CN520
17
R522
16
8
CN401
R520
IC520
R473
C467
E
8
50
D
Q442
OPTICAL
PICK-UP
KMS-263A
5
5
R524
C529
C530
IC402
C426
IC521
C527
) : SIDE B
1
1
R415
R416
C
4
C534
C533
4
FB444
(
10
OWH
C513
C520
(Q400)
Q440
Q441
Q442
Q443
Q444
Q445
Q446
Q447
Q510
Q511
Q512
Q520
OVER WRITE
HEAD
R523
E-5
D-5
C-7
F-6
F-3
F-1
A-7
D-2
A
R478
C472 R479
C462
R480
Q444 R450
R451 C445
R453 R452
D441
IC400
IC401
IC402
(IC403)
IC440
IC442
IC510
IC520
C510
CN440
Location
F-5
F-3
B-6
B-6
C-4
C-5
C475
L444
Ref. No.
D440
D441
D510
D511
D520
D521
5
6
1-672-770- 15
7
MDX-C800REC
SERVO BOARD (SIDE B)
C511
A
B
C
C410
D
C411
E
R403
C417
R409
C419
C420
R412
C406
C416
R408
R411
C404
C403
C402
L400
IC403
1
8
4
5
C428
L401
C407 C408
C429
R421
R420
RB403
RB405 RB404
C423
Q400
F
C400
C424
R413 R414
C401
1-672-77004
7
6
5
4
3
35
2
35
1
15
MDX-C800REC
(Page 37)
• Refer to page 33 for Waveforms.
3-7. SCHEMATIC DIAGRAM — SERVO SECTION (1/3) — • Refer to page 52 for IC Block Diagrams.
Note:
• Voltage is dc with respect to ground under no-signal
condition.
no mark : MD PLAY
(
) : MD REC
(Page 38)
36
36
MDX-C800REC
(Page 41)
(Page 44)
(Page 36)
COMPUTER BOARD
• Refer to page 33 for Waveforms.
3-8. SCHEMATIC DIAGRAM — SERVO SECTION (2/3) — • Refer to page 52 for IC Block Diagrams.
Note:
• Voltage is dc with respect to ground under no-signal
condition.
no mark : MD PLAY
(
) : MD REC
: Impossible to measure
∗
(Page 38)
37
37
MDX-C800REC
• Refer to page 33 for Waveforms.
3-9. SCHEMATIC DIAGRAM — SERVO SECTION (3/3) — • Refer to page 52 for IC Block Diagrams.
(Page 37)
(Page 39)
(Page 36)
Note:
• Voltage is dc with respect to ground under no-signal
condition.
no mark : MD PLAY
(
) : MD REC
38
38
MDX-C800REC
3-10. PRINTED WIRING BOARD — SENSOR SECTION —
3-11. SCHEMATIC DIAGRAM — SENSOR SECTION —
(Page 34)
SERVO BOARD
CN520
6
SENSOR BOARD (SIDE A)
C553
1
C557
M503
(SPINDLE)
CN550
RED
B
C554
C555
2
1
YEL
CN551
BLK
BLK
M501
(SLED)
(Page 38)
17
C558
C556
2
1
C559
1-672-771SW554
(REC-P)
BLK
CN552
A
SW550
(LIMIT-IN)
RED
M502
(LOADING)
15
SW555
(PLAY-P)
1
2
SENSOR BOARD (SIDE B)
1
2
3
4
3
4
SW551
-2
(REFLECT)
-1
(PROTECT)
SW552
(DISC-IN)
B
SW553
(PACK-IN))
A
1-672-771-
15
04
39
39
MDX-C800REC
3-12. PRINTED WIRING BOARD — COMPUTER SECTION —
IC560
R597
R602
91
RB562
1
7
120
X560
IC561
R618 R619
R613
8
14
15
1-672-772-
1
2
3
4
2
3
4
R631
2
50
7
R562
R567
R568
R617
C564
8
R570
R612
C562
R615 R623 R624
R564 C560
IC562
C578
RB561
L560
C561
14
C563
R579
1
51
R585
R583
R581
R578
IC564
5 4
1 3
R633
C571
R628
A
Q561
C573
3 1
IC563
4 5
1
R606
R608
D561
R584
R582
R580
R635
R576
Q562
R630
R629
5
CN560
R575
B
R603
C569
5
R614
R610
5
SERVO BOARD
CN401 (Page 34)
COMPUTER BOARD (SIDE B)
1
R632
R565
1
R601
B
90
R616
R600
(Page 42)
C574
R563
R561
R560 R627
R620
D560
MAIN BOARD
CN823
C575
R574
R572
R573
C570
4
) : SIDE B
R569 R622
30
R588
A-2
B-3
61
CN561
R589
(Q561)
(Q562)
A
R599
A-3
B-4
A-2
A-1
A-2
31
15
R595
IC560
IC561
(IC562)
(IC563)
(IC564)
60
1
C568
Location
B-2
A-3
C579
(
Ref. No.
D560
(D561)
R625
• Semiconductor
Location
R566
COMPUTER BOARD (SIDE A)
1-672-772-
04
40
40
15
MDX-C800REC
(Page 44)
(Page 37)
• Refer to page 33 for Waveforms.
3-13. SCHEMATIC DIAGRAM — COMPUTER SECTION — • Refer to page 52 for IC Block Diagrams.
41
41
MDX-C800REC
• Semiconductor
Location (SIDE A)
Ref. No.
D1
D100
D101
D102
D103
D200
D201
D202
D203
D650
D700
D701
D714
D716
D719
D721
D722
D723
D780
D781
D782
D783
D784
D787
D788
D789
D822
D824
D825
D826
D827
D828
D829
D830
D831
D832
D833
D834
D835
D836
D837
D838
Location
F-12
B-7
B-7
B-8
B-8
B-7
B-6
B-8
B-8
J-8
J-13
B-5
K-2
K-9
K-5
C-9
C-10
C-9
B-4
C-3
C-3
B-3
B-2
C-3
D-4
D-1
I-2
C-4
B-4
B-5
B-5
B-5
B-5
C-4
C-5
B-4
B-4
E-7
E-7
E-6
F-6
H-3
IC102
IC284
IC300
IC301
IC650
IC651
IC652
IC700
IC701
IC702
IC780
IC801
IC802
C-11
G-6
H-4
H-4
J-6
H-7
K-8
I-11
K-13
K-11
C-4
D-7
G-4
Q1
Q2
Q3
Q103
Q201
Q300
Q651
Q700
Q701
Q702
Q703
Q704
Q705
Q780
Q781
Q784
Q822
Q823
Q825
Q826
Q830
Q831
Q833
F-13
F-12
F-12
C-8
C-7
H-3
I-8
I-13
C-6
K-13
C-10
B-9
C-10
B-4
C-4
D-1
C-5
D-4
D-6
D-7
G-7
H-3
I-2
3-14. PRINTED WIRING BOARDS — MAIN SECTION —
(Page 40)
(Page 34)
42
42
MDX-C800REC
• Semiconductor
Location (SIDE B)
(Page 48)
43
43
Ref. No.
D702
D717
D718
D785
D786
D820
D821
D839
D840
D841
Location
B-1
J-3
K-5
C-3
C-3
B-3
F-2
I-2
J-3
J-1
IC104
IC280
A-7
G-1
Q102
Q200
Q782
Q783
Q821
Q824
Q827
Q828
Q829
Q832
Q834
Q835
Q836
B-11
B-11
B-3
B-3
I-1
D-5
D-5
E-4
D-4
H-3
I-2
J-2
J-2
MDX-C800REC
(Page 47)
(Page 41)
(Page 45)
(Page 37)
• Refer to page 49 for Waveforms.
3-15. SCHEMATIC DIAGRAM — MAIN SECTION (1/4) — • Refer to page 52 for IC Block Diagrams.
(Page 46)
Note:
• Voltage is dc with respect to ground under no-signal
(detuned) condition.
no mark : FM
44
44
MDX-C800REC
(Page 46)
(Page 44)
3-16. SCHEMATIC DIAGRAM — MAIN SECTION (2/4) — • Refer to page 52 for IC Block Diagrams.
Note:
• Voltage is dc with respect to ground under no-signal
(detuned) condition.
no mark : FM
(Page 47)
45
45
MDX-C800REC
• Refer to page 49 for Waveforms.
3-17. SCHEMATIC DIAGRAM — MAIN SECTION (3/4) — • Refer to page 52 for IC Block Diagrams.
(Page 47)
(Page 45)
(Page 44)
Note:
• Voltage is dc with respect to ground under no-signal
(detuned) condition.
no mark : FM
(
) : AM
46
46
MDX-C800REC
• Refer to page 49 for Waveforms.
3-18. SCHEMATIC DIAGRAM — MAIN SECTION (4/4) — • Refer to page 52 for IC Block Diagrams.
(Page 46)
(Page 44)
(Page 45)
(Page 49)
Note:
• Voltage is dc with respect to
ground under no-signal
(detuned) condition.
no mark : FM
(
) : AM
<
> : MD PLAY
47
47
MDX-C800REC
3-19. PRINTED WIRING BOARD — RELAY SECTION —
(Page 43)
• Semiconductor
Location
(
48
48
Ref. No.
(D800)
(D801)
(D802)
(D803)
(D804)
(D805)
(D806)
(D807)
(D808)
(D809)
(D810)
(D811)
Location
C-1
C-1
C-1
B-2
B-2
B-2
B-2
B-2
B-2
B-2
B-2
C-2
LED800
B-7
) : SIDE B
(Page 50)
MDX-C800REC
3-20. SCHEMATIC DIAGRAM — RELAY SECTION —
• Waveforms (MODE:MD PLAY)
(MAIN BLOCK)
1
0.8Vp-p
IC301
(2A)
3
2
3.6Vp-p
24µsec
IC300
qs
(LRCK)
3
4.7Vp-p
(Page 51)
(Page 47)
0.35µsec
IC300
qd
(SCLK)
4
0.9Vp-p
18.432MHz
IC650
ih
(EXTAL)
5
1.8Vp-p
32.768kHz
IC700
uf
(XOA)
6
2.5Vp-p
3.6864MHz
IC700
49
49
os
(XO)
MDX-C800REC
3-21. PRINTED WIRING BOARD — KEY SECTION —
• Semiconductor Location
(
Ref. No.
(D901)
(D902)
(D903)
(D904)
(D950)
D961
(D962)
Location
B-10
B-10
B-12
B-12
A-5
C-4
B-5
Ref. No.
LED903
LED951
LED952
LED953
LED954
LED955
LED956
Location
C-2
B-5
B-5
A-5
A-12
B-12
B-12
IC960
(IC970)
(IC980)
C-6
B-7
B-9
LED900
LED901
LED902
A-4
C-4
A-2
(Q942)
(Q943)
(Q944)
(Q945)
(Q950)
(Q951)
(Q952)
B-2
B-1
B-13
B-13
A-5
A-5
A-4
(Page 48)
) : SIDE B
50
50
MDX-C800REC
(Page 49)
3-22. SCHEMATIC DIAGRAM — KEY SECTION —
Note:
• Voltage is dc with respect to ground under no-signal
(detuned) condition.
no mark : FM
51
51
MNT2 3
EACH
BLOCK
I
J
72 AVSS
SCLK 6
EACH
BLOCK
CPU I/F
SRDT 8
ADDC
COMPP
COMPO
AGCI
RF AGC
RF
PEAK
OPN
–1
–
–
–2
2
40
39
38
37
RF AGC
+
–
EQ
USRC
RFA3
HLPT
–1
EQ
CVB
VC
3
AUX
SW
PEAK3T
3T
P-P
–2
OFST
3T
PTGR
WBL
TEMP
PEAK
–
1
–
–2
70 ADRT
68 ADIO
OPO
RFO
1
71 ADRB
69 AVDD
41
DET
73 SE
SWDT 5
43 42
RFA2
74 TE
ADIP
DECODER
44
USROP
BPF3T
75 AUX2
MNT3 4
XLAT 7
45
–
+
AUTO
SEQUENCER
PWM
GENERATOR
SPINDLE
SERVO
MONITOR
CONTROL
46
–
+
MNT1 2
47
92 91 90 89 88 87 86 85 84 83 82 81 80 79 78 77 76
RFA1
MNT0 1
MORFI
DCHG
APC
ADFG
F0CNT
XLRF
CKRF
DTRF
APCREF
LDDR
TRDR
TFDR
DVDD
FFDR
FRDR
FS4
SRDR
SFDR
94 93
48
+
–
100 99 98 97 96 95
SPRD
SPFD
FGIN
TEST1
TEST2
TEST3
DVSS
EFMO
IC400 CXD2652AR
MORFO
IC440 CXA2523AR
• IC Block Diagrams
–2
BOTTOM
PBSW
GRVA
36 BOTM
PBH
–1
GRV
WBL
35 ABCD
67 VC
SERVO
DSP
SENS 9
A/D
CONVERTER
66 AUX1
A
65 FE
ANALOG
MUX
IVR
64 ABCD
XRST 10
+
–
4
34 FE
–
–
–
–
AA
33 AUX
BPFC
ABCDA
63 BOTM
SQSY 11
DQSY 12
32 ADFG
62 PEAK
SUBCODE
PROCESSOR
B
PLL
XINT 14
IVR
31 ADAGC
BB
+
+
–
–
60 FILO
59 FILI
EFM/ACIRC
ENCODER/
DECODER
SHOCK RESISTANT
MEMORY CONTROLLER
+
–
5
61 CLTV
RECP 13
58 PCO
C
+
–
6
IVR
57 PDO
TX 15
CC
DET
BPF22
56 AVSS
–
–
+
+
OSCI 16
OSCO 17
XTSL 18
EACH
BLOCK
CLOCK
GENERATOR
D
DIGITAL
AUDIO
I/F
NC 19
DVSS 20
+
–
7
55 RFI
COMP
SAMPLING
RATE
CONVERTER
30 ADIN
FEA
IVR
ADIP
AGC
WBL
ATA
29 ADFM
DD
54 BIAS
WBL
–1
53 AVDD
DIN 21
52 ASYI
DOUT 22
E
+
–
8
51 ASYO
IVR
+
–
EE
PTGR
–
+
–
+
EE'
–2
–1
TESW
EBAL
–2
ESW
ATRAC
ENCODER/DECODER
DADT 24
F
+
–
9
IVR
FF
LRCK 25
IV
3T
AUXSW
50
+
25 WBLADJ
VI CONV
BGR
COMMAND
–
MVCI
D3
D2
D0
D1
XWE
XRAS
A09
XCAS
XOE
DVSS
A11
A08
A07
A06
A05
A04
A10
A01
A00
A02
A03
DVDD
FS256
XBCK
29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49
26 TE
TEA
EQ
PD 10
26 27 28
TG
WBL
FF'
FBAL
GSW
ADDRESS/DATA BUS A00 - A11, D0 - D3
+
–
28 SE
SEA
27 CSLED
EFB
ADDT 23
TG
+ –
VREF
SCRI - PARA
DECODE
APC 11
APCREF 12
VM1
IN1F
IN1R
VDD
21
20
19
18
17
CHARGE
PUMP.
OSC
AMP
AMP
PREDRIVE
INTERFACE
VDD
NC
AMP
AMP
INTERFACE
CD
IC702 RN5VD33AA-TL
5
4
PREDRIVE
VCC
OUT1F
22
24
3TADJ
PGND1
23
22 23
EQADJ
OUT1R
24
21
VREF
VM12
25
20
F0CNT
OUT2R
26
19
XSTBY
PGND2
27
18
XLAT
OUT2F
28
17
SCLK
VM2
29
16
SWDT
IN2F
30
15
TEMPR
IN2R
31
14
TEMPI
CAPA+
32
13
GND
CAPA–
IC520 BH65111FS-E2
IC521 BA6287F-T1
OUT1 1
8 GND
VM 2
7 OUT2
RESET
DRIVER
PREDRIVE
AMP
INTERFACE
PSB
2
3
GND
AMP
1
VDD
AMP
AMP
INTERFACE
DRIVER
TSD
OUT
PREDRIVE
VCC 3
CONTROL LOGIC
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
GND
VG
IN4R
IN4F
VM4
OUT4F
PGND4
OUT4R
VM34
OUT3R
PGND3
OUT3F
VM3
IN3F
IN3R
PSB
6 VREF
1
POWER
SAVE
FIN 4
52
52
5 RIN
IC402 AT24C16N-10SI-TR
START
STOP
LOGIC
IC780 BA8270F
SERIAL EN
CONTROL
LOGIC
8 VCC
COMP
R/W
DATA RECOVERY
DATA WORD
ADDR/COUNTER
RST 2
RESET
SWITCH
BATT 3
BATTERY
SWITCH
14 VCC
13
12
11
10
RST
BUS ON
CLK IN
BU IN
7 TST
CLK 4
VREF 5
DATA 6
LOAD INC
6 SDL
X DEC
A0 1
A1 2
A2 3
BUS ON
SWITCH
H.V. PUMP/TIMING
LOAD
DEVICE
ADDRESS
COMPARATOR
BUS ON 1
E2PROM
9 DATA IN
5 SDA
GND 7
8 DATA OUT
GND 4
Y DEC
SERIAL MUX
DOUT/ACK
LOGIC
DIN
DOUT
IC301 TC7WU04FU
1A
1
8
VCC
3Y
2
7
1Y
2A
3
6
3A
GND
4
5
2Y
IC280 BA4908
REGULATOR
OVER VOLTAGE
PROTECT
5
6
7
8
9
10
11
12
VDD
AMP
VCC
ANT
COM
AM
FM
GND
+
–
2 3 4
NC
+
–
1
MODE2
MODE1
STB
+
–
–
+
53
ACINLR
ACINRF
ACINRR
OUTLF
OUTLR
OUTRF
OUTRR
OUTSWL
OUTSWR
OUTSSL
OUTSSR
IC102 TDA7402TR
33 32 31
30
29
28
27
26
25
24 23
MIXER
MONO- MONOFADER FADER
ACINLF 34
SWINR 35
SWINL 36
ACIN
ACOUTR 37
ACOUTL 38
MAIN
MONO- MONOFADER FADER
MONO- MONOFADER FADER
FRONT
OUTPUT
SELECTOR
SUBWOOFER
+PHASE
CONTROL
REAR
SW
SECOND
CREF 39
22 VDD
IIC-BUS
LP
VOICE
BANDPASS
HP
21 SCL
20 SDA
BASS
SUPPLY
TREBLE
DIGITAL CONTROL
HIGH-CUT
VOLUME
SOFTMUTE
COMPANDER
19 GND
18 SM
S&H
PULSE
FORMER
25kHz
LP
QUAL
17 QUAL
LOUDNESS
LOUDNESS
+
IN-GAIN
IN-GAIN
+AUTO ZERO
MUTE
MULTIPATH
DETECTOR
DEMODULATOR
+STEREO ADJUST
+STEREO BLAND
MUX 40
BEEP
D/A
CONVERTER
PILOT
CANCELATION
16 MPOUT
15 MPIN
14 LEVEL
PIL DET
MAIN SOURCE
SELECTOR
54
PLL
MAIN
INPUT
MULTIPLEXER
80kHz
LP
FM
13 MPX
MAIN
CH0
AUX
AM
1 2
3 4 5 6
7 8 9 10
11
FD2L+
FD2L–
FD2R+
FD2R–
AM
PHONO
FD1L+
FD1L–
FD1R+
FD1R–
MD2 43
MD2G 44
SECOND SOURCE
SELECTOR
SEL
SER
MD1 41
MD1G 42
MIXING
SELECTOR
AM/FM
NOISE BLANKER
12 AMIF
IC300 AK4523VF-E2
COMMON VOLTAGE
28 VCOM
VREFH 1
AINR+ 2
AINR- 3
∆Σ
MODULATOR
DECIMATION
FILTER
HPF
8x
INTERPOLATOR
∆Σ
MODULATOR
LPF
27 AOUTR
AINL+ 4
AINL- 5
∆Σ
MODULATOR
DECIMATION
FILTER
HPF
8x
INTERPOLATOR
∆Σ
MODULATOR
LPF
26 AOUTL
VA 6
AGND 7
NC 8
NC 9
SERIAL I/O
INTERFACE
DIF0 10
DIF1 11
LRCK 12
SCLK 13
SDTI 14
CLOCK
DIVIDER
25
24
23
22
21
20
19
18
17
16
15
CMODE
PD
DGND
VD
NC
NC
MCKI
DEM1
DEM0
SMUTE
SDTO
TEST
NC
SEL
17
16 15
14 13 12 11 10
MULTIPLEXER
REGISTER
REGISTER
REGISTER
B
A
AOUT
18
NC
C
GND
IC652 BA3834F
DECODER
REGISTER
REGISTER
REGISTER
REGISTER
PEAK
HOLD
PEAK
HOLD
PEAK
HOLD
PEAK
HOLD
PEAK
HOLD
PEAK
HOLD
PEAK
HOLD
68Hz
B.P.F.
170Hz
B.P.F.
420Hz
B.P.F.
1kHz
B.P.F.
2.4kHz
B.P.F.
5.9kHz
B.P.F.
14.4kHz
B.P.F.
1 2 3 4
5
6
7 8
9
BIASC
VREFC
RREF
NC
DIFOUT
NC
CIN
AIN
VCC
DIFFERENTIAL
AMPLIFIER
55
REF
OUT
S.C.P
NON-INVINPUT2
INVINPUT2
FEED
BACK2
DEAD
TIME
CONTROL2
OUT2
VCC
IC801 TL1451ACDB
16
15
14
13
12
11
10
9
VERF.
+2.5V
VCC
–
+
REFERENCE
VOLTAGE
SHORT
CIRCUIT
PROTECTION
COMPARATOR
+
+
–
VREF/2
VERF
VERF
VERF
S R
LATCH
R
U.V.L.O
OUTPUT2
OUTPUT1
PWM
COMPARATOR1
+
–
TRIANGLE
OSCILLATOR
56
PWM
COMPARATOR2
ERROR
AMP2
+2.5V
3
4
5
6
7
8
RT
NON-INVINPUT1
INVINPUT1
FEED
BACK1
DEAD
TIME
CONTROL1
OUT1
GND
GND
2
CT
ERROR
AMP1
1
SECTION 4
EXPLODED VIEWS
NOTE:
• The mechanical parts with no reference
number in the exploded views are not supplied.
• Items marked “*” are not stocked since
they are seldom required for routine service.
Some delay should be anticipated
when ordering these items.
• -XX and -X mean standardized parts, so
they may have some difference from the
original one.
• Color Indication of Appearance Parts
Example :
KNOB, BALANCE (WHITE) ... (RED)
R
R
Parts Color Cabinet’s Color
• Accessories and packing materials and
hardware (# mark) list are given in
the last of this parts list.
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
Les composants identifiés par une
marque 0 sont critiques pour
la sécurité.
Ne les remplacer que par une piéce
portant le numéro spécifié.
4-1. SUB PANEL SECTION
11
8
12
20
8
#1
13
14
10
#2
19
A
15
18
16
8
6
5
2
1
8
3
7
8
17
#1
#1
9
4
#3
#1
#3
A
#4
#3
#1
#1
Ref. No.
Part No.
Description
Ref. No.
Part No.
Description
1
2
3
4
* 5
X-3378-496-1
3-040-990-01
3-025-484-01
3-039-574-21
1-678-397-11
PANEL ASSY, SUB
BUTTON (EJECT)
SPRING (DOOR)
DOOR (MD)
RELAY BOARD
Remark
11
* 12
13
14
* 15
1-790-926-21
3-047-278-01
1-791-560-11
1-792-861-11
3-043-422-01
CORD (WITH CONNECTOR) (POWER)
SHEET (REC/MD)
CABLE, SHIELD FLEXIBLE FLAT
CABLE, FLEXIBLE FLAT
BRACKET (F) (MD)
6
7
8
9
* 10
X-3376-699-2
3-030-909-02
3-713-786-51
X-3377-621-2
3-022-316-61
GEAR ASSY
DAMPER, OIL
SCREW +P 2X3
LOCK ASSY
COVER
* 16
* 17
* 18
19
* 20
3-043-423-01
3-039-558-01
1-678-826-11
3-376-464-11
3-033-640-21
BRACKET (R) (MD)
CASE (77), SHIELD
CONNECTION BOARD
SCREW (+PTT 2.6X6), GROUND POINT
CASE (U), SHIELD
Remark
57
4-2. FRONT PANEL SECTION
#5
#5
54
68
#5
53
not supplied
(KEY board)
56
65
66
LCD900
64
63
62
60
61
52
59
58
51
57
67
55
Ref. No.
Part No.
Description
51
52
* 53
54
55
3-040-980-01
3-042-458-01
3-040-992-01
X-3378-498-1
X-3379-161-1
* 56
57
58
59
60
3-040-993-01
3-041-005-21
3-040-989-01
3-049-081-01
3-041-010-01
58
Remark
Ref. No.
Part No.
Description
BUTTON (SOURCE)
KNOB (VOL-DSO)
HOLDER (LCD)
PANEL ASSY, FRONT BACK
PANEL ASSY, FRONT
61
62
63
* 64
65
3-041-003-01
3-040-987-02
3-040-986-01
3-040-997-01
1-694-660-11
BUTTON (LIST/ENTER)
BUTTON (OFF)
BUTTON (MENU/SOUND)
PLATE (LCD), GROUND
CONDUCTIVE BOARD, CONNECTION
PLATE (LCD), LIGHT GUIDE
BUTTON (D)
BUTTON (OPEN)
SPRING (OPEN)
BUTTON (1-6/M)
* 66
67
68
LCD900
3-046-372-01
3-041-020-01
3-048-250-01
1-803-912-11
SHEET (REFLECTOR)
BUTTON (REC MENU)
CUSHION (OFF)
DISPLAY PANEL, LIQUID CRYSTAL
Remark
4-3. CHASSIS SECTION
#7
109
#7
#7
108
105
#7
#7
103
110
#7
106
107
#7
#7
#6
#6
TU1
#6
F901
103
111
104
102
101
Ref. No.
Part No.
Description
* 101
* 102
103
* 104
* 105
3-022-311-41
3-047-309-01
3-376-464-11
A-3294-973-A
3-041-063-01
CHASSIS
SHEET, INSULATING
SCREW (+PTT 2.6X6), GROUND POINT
MAIN BOARD, COMPLETE
HEAT SINK (REC)
* 106
* 107
3-043-424-01 BRACKET (IC)
3-043-425-01 HEAT SINK (REG/REC)
Remark
Ref. No.
*
*
*
*
Part No.
Description
108
109
110
111
F901
3-043-421-01
1-678-398-11
3-048-454-01
3-043-497-01
1-532-877-11
BRACKET (PC BOARD)
DIGITAL BOARD
SHIELD (COVER)
SHEET, INSLATING (2)
FUSE (BLADE TYPE) (AUTO FUSE) 10A
TU1
A-3220-738-A TUNER UNIT (TUX-020)
Remark
59
4-4. MD MECHANISM SECTION (1)
(MG-715B-160)
151
152
151
154
153
155
151
151
#8
160
167
#11
159
#8
167
156
#8
#11
158
168
F
157
D
161
158
169
162
163
164
168
E
161
163
#9
F
165
#11
#11
#9
166
D
#9
#9
#9
#9
E
#9
Ref. No.
Part No.
Description
Ref. No.
Part No.
Description
151
152
153
154
155
3-321-813-21
3-038-515-01
3-030-222-01
3-030-191-01
3-030-198-03
WASHER, COTTER POLYETHYLENE
RING, RETAINING
SPRING (T), TENSION
SLIDER (T)
SPRING (LIMITER), TORSION
161
* 162
163
* 164
* 165
3-931-897-31
X-3376-409-1
3-030-194-02
X-3376-410-1
3-030-174-12
DAMPER (T)
CHASSIS (L) ASSY
SPRING (F), TENSION
CHASSIS (R) ASSY
CHASSIS (M)
* 156
157
158
159
* 160
X-3376-408-3
X-3376-415-1
3-030-195-01
1-790-418-11
A-3317-980-A
CHASSIS (T) ASSY
ARM (OWH) ASSY
SPRING (B), TENSION
MICRO COMPUTER FLEXIBLE BOARD
COMPUTER BOARD, COMPLETE
* 166
167
168
169
A-3326-079-A
3-030-190-01
3-931-897-51
3-038-671-01
SERVO BOARD, COMPLETE
LEVER (LK)
DAMPER (T)
SPRING (OWH), TORSION
60
Remark
Remark
4-5. MD MECHANISM SECTION (2)
(MG-715B-160)
#9
#9
#9
204
206
201
205
224
M502
202
207
203
208
211
M501
209
210
#11
216
216
#11
#11
214
M503
212
#6
#6
#11
218
217
217
213
216
215
#11
219
#11
#11
220
221
222
223
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
Ref. No.
Remark
Ref. No.
Les composants identifiés par une
marque 0 sont critiques pour la
sécurité.
Ne les remplacer que par une piéce
portant le numéro spécifié.
Part No.
Description
Part No.
Description
201
202
203
204
205
X-3376-412-2
3-030-176-03
3-030-197-02
3-342-375-11
4-987-061-01
BRACKET (LD) ASSY
WHEEL (LD), WORM
LEVER (OPS)
SCREW (M1.7X1.4), SPECIAL
SPACER (RACK)
215
216
217
218
219
3-030-188-01
3-965-550-02
3-030-187-01
3-030-185-01
1-790-416-11
SPRING (SL), LEAF
SCREW (M1.7X1.6)
BASE (SLB)
SHAFT (SLB)
SENSOR FLEXIBLE BOARD
206
0 207
208
209
210
4-996-265-01
8-583-057-02
3-030-199-03
3-366-890-11
1-790-417-11
SHAFT, MAIN
PICK-UP, OPTICAL KMS-263A/J1N
RACK (INSERT)
SCREW (M1.4)
OP FLEXIBLE BOARD
220
221
222
223
224
A-3317-305-A
1-790-434-11
1-500-412-21
4-988-560-01
3-047-912-01
SENSOR BOARD, COMPLETE
OWH FLEXIBLE BOARD
HEAD, OVER WRITE (RF325-74A)
SCREW (+P 1.7X6)
COVER, OP
211
212
213
214
X-3376-559-1
3-030-181-01
3-345-648-01
3-030-186-01
SHAFT (FEED) ASSY
BRACKET (SL)
SCREW (M1.4X3)
BASE (SLA)
M501
M502
M503
X-3376-526-1 MOTOR ASSY, SLED (SLED)
X-3376-525-1 MOTOR ASSY, LOADING (LOADING)
A-3301-942-A MOTOR ASSY, SPINDLE (SPINDLE)
Remark
61
4-6. MD MECHANISM SECTION (3)
(MG-715B-160)
251
252
253
254 253
255
253
261
256
257
259
256
253
258
262
260
263
262
253
264
265
261
Ref. No.
Part No.
Description
251
252
253
254
255
X-3376-418-7
X-3376-413-2
3-321-813-21
3-030-180-01
3-030-178-03
HOLDER ASSY
SLIDER (LK) ASSY
WASHER, COTTER POLYETHYLENE
GEAR (CAM)
GEAR (LD2)
256
257
258
3-038-515-01 RING, RETAINING
3-030-177-02 GEAR (LD1)
X-3376-414-1 SLIDER (LD) ASSY
62
Remark
Ref. No.
Part No.
Description
259
260
261
262
263
3-880-990-00
X-3376-420-4
3-038-514-01
3-030-189-01
X-3376-421-2
SCREW (1.7X3), FLAT, (+) SPECIAL
SLIDER (L) ASSY
RING, RETAINING
LEVER (HOOK)
SLIDER (R) ASSY
264
265
3-030-223-01 SPRING (OPS), TORSION
X-3376-406-5 CHASSIS (OP) ASSY
Remark
SECTION 5
ELECTRICAL PARTS LIST
NOTE:
• Due to standardization, replacements in
the parts list may be different from the
parts specified in the diagrams or the
components used on the set.
• -XX and -X mean standardized parts, so
they may have some difference from the
original one.
• RESISTORS
All resistors are in ohms.
METAL:Metal-film resistor.
METAL OXIDE: Metal oxide-film resistor.
F:nonflammable
• Items marked “*” are not stocked since
they are seldom required for routine service.
Some delay should be anticipated
when ordering these items.
• SEMICONDUCTORS
In each case, u : µ, for example:
uA.. : µA.. uPA.. : µPA..
uPB.. : µPB.. uPC.. : µPC.. uPD.. : µPD..
• CAPACITORS
uF : µF
• COILS
uH : µH
COMPUTER
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
Les composants identifiés par une
marque 0 sont critiques pour
la sécurité.
Ne les remplacer que par une piéce
portant le numéro spécifié.
When indicating parts by reference
number, please include the board.
Ref. No.
Part No.
Description
Remark
*
A-3317-980-A COMPUTER BOARD, COMPLETE
**************************
< CAPACITOR >
C560
C561
C562
C563
C564
1-107-826-11
1-107-826-11
1-107-826-11
1-107-826-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
10%
10%
10%
10%
10%
16V
16V
16V
16V
16V
C568
C569
C570
C571
C573
1-162-927-11
1-107-826-11
1-107-826-11
1-107-826-11
1-131-618-21
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
100PF
0.1uF
0.1uF
0.1uF
22uF
5%
10%
10%
10%
20%
50V
16V
16V
16V
12.5V
C574
C575
C578
C579
1-119-751-11
1-162-970-11
1-109-982-11
1-107-826-11
TANTAL. CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
22uF
0.01uF
1uF
0.1uF
20%
10%
10%
10%
16V
25V
10V
16V
< CONNECTOR >
CN560
CN561
1-774-930-21 CONNECTOR, FFC/FPC 51P
1-573-355-11 CONNECTOR, FFC/FPC 15P
< DIODE >
D560
D561
8-719-988-61 DIODE 1SS355TE-17
8-719-988-61 DIODE 1SS355TE-17
< IC >
IC560
IC561
IC562
IC563
IC564
8-759-678-04
8-759-238-47
8-759-238-47
8-759-495-76
8-759-271-86
IC
IC
IC
IC
IC
MB90574PFV-G-297-BND
TC74HCT7007AF(EL)
TC74HCT7007AF(EL)
RN5VD33AA-TL
TC7SH04FU-TE85R
< COIL >
L560
1-412-058-11 INDUCTOR CHIP 10uH
< TRANSISTOR >
Q561
Q562
8-729-900-53 TRANSISTOR DTC114EKA-T146
8-729-106-60 TRANSISTOR 2SB1132-T101-QR
< RESISTOR >
R560
R561
1-216-809-11 METAL CHIP
1-216-809-11 METAL CHIP
100
100
5%
5%
1/16W
1/16W
Ref. No.
Part No.
Description
Remark
R562
R563
R564
R565
R566
1-216-809-11
1-216-809-11
1-216-797-11
1-216-845-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
10
100K
100K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R567
R568
R569
R570
R572
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
100
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R573
R574
R575
R576
R578
1-216-809-11
1-216-809-11
1-216-809-11
1-216-845-11
1-216-797-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
100K
10
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R579
R580
R581
R582
R583
1-216-797-11
1-216-847-11
1-216-845-11
1-216-845-11
1-216-847-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10
150K
100K
100K
150K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R584
R585
R588
R589
R595
1-216-847-11
1-216-845-11
1-216-797-11
1-216-845-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
150K
100K
10
100K
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R597
R599
R600
R601
R602
1-216-809-11
1-216-864-11
1-216-821-11
1-216-845-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
0
1K
100K
1K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R603
R606
R608
R610
R612
1-216-797-11
1-216-845-11
1-216-845-11
1-216-864-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10
100K
100K
0
1K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R613
R614
R615
R616
R617
1-216-821-11
1-216-825-11
1-216-825-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
2.2K
2.2K
100
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R618
R619
R620
R622
R623
1-216-809-11
1-216-809-11
1-216-821-11
1-216-821-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
1K
1K
1K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
63
COMPUTER
Ref. No.
DIGITAL
CONNECTION
Remark
KEY
Part No.
Description
Part No.
Description
R624
R625
R627
R628
R629
1-216-825-11
1-216-825-11
1-216-825-11
1-218-712-11
1-216-065-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
RES-CHIP
2.2K
2.2K
2.2K
6.8K
4.7K
5%
5%
5%
0.5%
5%
1/16W
1/16W
1/16W
1/16W
1/10W
Ref. No.
C973
C974
C975
C980
C981
1-165-176-11
1-115-412-11
1-107-826-11
1-107-826-11
1-165-176-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.047uF
680PF
0.1uF
0.1uF
0.047uF
10%
5%
10%
10%
10%
16V
25V
16V
16V
16V
Remark
R630
R631
R632
R633
R635
1-216-065-11
1-216-073-00
1-216-845-11
1-216-845-11
1-216-853-11
RES-CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
10K
100K
100K
470K
5%
5%
5%
5%
5%
1/10W
1/10W
1/16W
1/16W
1/16W
C982
C983
C984
C985
1-165-176-11
1-165-176-11
1-115-412-11
1-115-467-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.047uF
0.047uF
680PF
0.22uF
10%
10%
5%
10%
16V
16V
25V
10V
< CONNECTOR >
< NETWORK RESISTOR >
CN901
RB561
RB562
1-233-810-21 RES, NETWORK
1-233-810-21 RES, NETWORK
< DIODE >
< VIBRATOR >
X560
1-781-002-21 VIBRATOR, CERAMIC (3.6MHz)
*************************************************************
1-678-826-11 CONNECTION BOARD
******************
*
1-794-065-11 PLUG, CONNECTOR 14P
100K (3216)
100K (3216)
D901
D902
D903
D904
D950
8-719-056-82
8-719-056-82
8-719-056-82
8-719-056-82
8-719-042-17
DIODE
DIODE
DIODE
DIODE
DIODE
UDZ-TE-17-6.2B
UDZ-TE-17-6.2B
UDZ-TE-17-6.2B
UDZ-TE-17-6.2B
HZU4.3B1RTF
D961
D962
8-719-976-99 DIODE UDZ-TE-17-5.1B
8-719-976-99 DIODE UDZ-TE-17-5.1B
< CAPACITOR >
< ROTARY ENCODER >
C899
1-163-133-00 CERAMIC CHIP 470PF
5%
50V
*************************************************************
*
1-678-398-11 DIGITAL BOARD
*************
*
3-043-421-01 BRACKET (PC BOARD)
EN900
1-475-014-11 ENCODER, ROTARY
< IC >
IC960
IC970
IC980
8-749-012-25 IC RS-170-TU
8-759-653-26 IC LC75878W
8-759-653-26 IC LC75878W
< BUZZER >
< JUMPER RESISTOR >
BZ800
1-504-920-11 BUZZER
JR901
1-216-295-00 SHORT
0
< CONNECTOR >
< LIQUID CRYSTAL DISPLAY >
CN803 1-750-862-21 PIN, CONNECTOR (PC BOARD) 5P
J800
1-793-262-21 PLUG, CONNECTOR (DIGITAL IN)
*************************************************************
LCD900 1-803-912-11 DISPLAY PANEL, LIQUID CRYSTAL
< DIODE >
KEY BOARD
**********
1-694-660-11
3-040-992-01
3-040-993-01
3-040-997-01
3-046-372-01
*
*
*
*
LED900 8-719-026-38 LEDIODE CL-150SR-CD-T
(RING ILLUMINATION)
LED901 8-719-026-38 LEDIODE CL-150SR-CD-T
(RING ILLUMINATION)
LED902 8-719-026-38 LEDIODE CL-150SR-CD-T
(RING ILLUMINATION)
LED903 8-719-026-38 LEDIODE CL-150SR-CD-T
(RING ILLUMINATION)
LED951 8-719-078-19 LEDIODE LWA673-R1S2 (LCD BACK LIGHT)
CONDUCTIVE BOARD, CONNECTION
HOLDER (LCD)
PLATE (LCD), LIGHT GUIDE
PLATE (LCD), GROUND
SHEET (REFLECTOR)
< CAPACITOR >
C960
C961
C962
C970
C971
1-107-826-11
1-107-826-11
1-107-823-11
1-115-467-11
1-165-176-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.47uF
0.22uF
0.047uF
10%
10%
10%
10%
10%
16V
16V
16V
10V
16V
C972
1-165-176-11 CERAMIC CHIP
0.047uF
10%
16V
64
LED952
LED953
LED954
LED955
LED956
8-719-078-19
8-719-078-19
8-719-078-19
8-719-078-19
8-719-078-19
LEDIODE
LEDIODE
LEDIODE
LEDIODE
LEDIODE
LWA673-R1S2 (LCD BACK LIGHT)
LWA673-R1S2 (LCD BACK LIGHT)
LWA673-R1S2 (LCD BACK LIGHT)
LWA673-R1S2 (LCD BACK LIGHT)
LWA673-R1S2 (LCD BACK LIGHT)
MAIN
KEY
Ref. No.
Part No.
Description
Remark
Ref. No.
< SWITCH >
LSW900
LSW901
LSW902
LSW904
LSW906
1-771-883-11
1-771-476-11
1-771-476-11
1-771-476-11
1-771-476-11
SWITCH, TACTILE (WITH LED) (OFF)
SWITCH, KEY BOARD (WITH LED) (SOURCE)
SWITCH, KEY BOARD (WITH LED) (SOUND)
SWITCH, KEY BOARD (WITH LED) (MENU)
SWITCH, KEY BOARD (WITH LED) (DSPL)
LSW907
LSW909
LSW910
LSW921
LSW922
1-771-476-11
1-771-476-11
1-771-883-11
1-771-765-21
1-771-765-21
SWITCH, KEY BOARD (WITH LED) (LIST)
SWITCH, KEY BOARD (WITH LED) (ENTER)
SWITCH, TACTILE (WITH LED) (MODE)
SWITCH, KEY BOARD (WITH LED) (REC MENU)
SWITCH, KEY BOARD (WITH LED) (MD REC)
LSW923
LSW924
LSW925
LSW926
LSW927
1-771-765-21
1-771-883-11
1-771-883-11
1-771-883-11
1-771-883-11
SWITCH, KEY BOARD (WITH LED) (REC STOP)
SWITCH, TACTILE (WITH LED) (6)
SWITCH, TACTILE (WITH LED) (5)
SWITCH, TACTILE (WITH LED) (4)
SWITCH, TACTILE (WITH LED) (3/PGM)
LSW928 1-771-883-11 SWITCH, TACTILE (WITH LED) (2/SHUF)
LSW929 1-771-883-11 SWITCH, TACTILE (WITH LED) (1/REP)
Part No.
Description
R948
R949
R950
R951
R952
1-216-021-00
1-216-033-00
1-216-041-00
1-216-825-11
1-216-825-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
68
220
470
2.2K
2.2K
5%
5%
5%
5%
5%
Remark
1/10W
1/10W
1/10W
1/16W
1/16W
R953
R954
R955
R956
R960
1-216-180-00
1-216-180-00
1-216-180-00
1-216-037-00
1-216-809-11
RES-CHIP
RES-CHIP
RES-CHIP
METAL CHIP
METAL CHIP
180
180
180
330
100
5%
5%
5%
5%
5%
1/8W
1/8W
1/8W
1/10W
1/16W
R961
R962
R963
R964
R965
1-216-041-00
1-216-041-00
1-216-065-11
1-216-057-11
1-216-295-00
METAL CHIP
METAL CHIP
RES-CHIP
RES-CHIP
SHORT
470
470
4.7K
2.2K
0
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
R970
R976
R977
R978
R979
1-216-857-11
1-218-295-11
1-216-821-11
1-216-821-11
1-216-821-11
METAL CHIP
RES-CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1M
43K
1K
1K
1K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R985
R986
R987
R988
R989
1-218-295-11
1-216-857-11
1-216-821-11
1-216-821-11
1-216-821-11
RES-CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
43K
1M
1K
1K
1K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R993
R996
R997
R998
R999
1-216-037-00
1-216-029-00
1-216-037-00
1-216-029-00
1-216-037-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
330
150
330
150
330
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
< TRANSISTOR >
Q942
Q943
Q944
Q945
Q950
8-729-904-72
8-729-904-72
8-729-027-55
8-729-027-55
8-729-027-55
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTD143EK-T-146
DTD143EK-T-146
DTC143EKA-T146
DTC143EKA-T146
DTC143EKA-T146
Q951
Q952
8-729-106-60 TRANSISTOR 2SB1132-T101-QR
8-729-120-28 TRANSISTOR 2SC2412K-T-146-QR
< RESISTOR >
R901
R902
R903
R904
R905
1-219-286-11
1-219-286-11
1-219-286-11
1-218-847-11
1-218-851-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
680
680
680
1K
1.5K
2%
2%
2%
2%
2%
1/16W
1/16W
1/16W
1/16W
1/16W
R906
R907
R908
R909
R910
1-218-851-11
1-218-855-11
1-218-859-11
1-218-863-11
1-218-867-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
1.5K
2.2K
3.3K
4.7K
6.8K
2%
2%
2%
2%
2%
1/16W
1/16W
1/16W
1/16W
1/16W
R911
R921
R922
R923
R924
1-218-871-11
1-219-286-11
1-219-286-11
1-219-286-11
1-218-847-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
10K
680
680
680
1K
2%
2%
2%
2%
2%
1/16W
1/16W
1/16W
1/16W
1/16W
R925
R926
R927
R928
R929
1-218-851-11
1-218-851-11
1-218-855-11
1-218-859-11
1-218-863-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
1.5K
1.5K
2.2K
3.3K
4.7K
2%
2%
2%
2%
2%
1/16W
1/16W
1/16W
1/16W
1/16W
R942
R943
R946
R947
1-216-037-00
1-216-033-00
1-216-021-00
1-216-033-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
330
220
68
220
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
< SWITCH >
SW903
1-771-884-11 SWITCH, TACTILE (WITH LED) (SEEK/AMS
– . m)
SW905 1-771-884-11 SWITCH, TACTILE (WITH LED) (DISC+/PRST+)
SW908 1-771-884-11 SWITCH, TACTILE (WITH LED) (SEEK/AMS
+ > M)
SW911 1-771-884-11 SWITCH, TACTILE (WITH LED) (DISC–/PRST–)
*************************************************************
*
A-3294-973-A MAIN BOARD, COMPLETE
*********************
*
*
*
*
3-041-063-01
3-043-424-01
3-043-425-01
3-048-454-01
7-685-753-09
HEAT SINK (REC)
BRACKET (IC)
HEAT SINK (REG/REC)
SHIELD (COVER)
SCREW +PTT 3X10 (S)
7-685-794-09 SCREW +PTT 2.6X10 (S)
< CAPACITOR >
C1
C3
C4
C5
1-109-982-11
1-109-982-11
1-164-227-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
1uF
1uF
0.022uF
0.1uF
10%
10%
10%
10%
10V
10V
25V
16V
65
MAIN
Ref. No.
Part No.
Description
C6
C7
C8
C9
C10
1-164-227-11
1-164-346-11
1-163-233-11
1-162-970-11
1-164-156-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.022uF
1uF
18PF
0.01uF
0.1uF
Part No.
Description
25V
16V
50V
16V
25V
C302
C304
C305
C307
C308
1-107-826-11
1-126-603-11
1-107-826-11
1-126-603-11
1-107-826-11
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
0.1uF
4.7uF
0.1uF
4.7uF
0.1uF
10%
20%
10%
20%
10%
16V
35V
16V
35V
16V
C11
C12
C13
C17
C18
1-117-681-11
1-164-156-11
1-162-970-11
1-164-156-11
1-126-395-11
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
100uF
0.1uF
0.01uF
0.1uF
22uF
16V
25V
25V
25V
16V
C309
C310
C311
C314
C315
1-107-826-11
1-162-919-11
1-162-919-11
1-163-227-11
1-163-243-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
22PF
22PF
10PF
47PF
10%
5%
5%
0.5PF
5%
16V
50V
50V
50V
50V
C19
C20
C21
C22
C25
1-162-968-11
1-115-467-11
1-162-968-11
1-107-823-11
1-115-156-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.0047uF
0.22uF
0.0047uF
0.47uF
1uF
10%
10%
10%
10%
50V
10V
50V
16V
10V
C316
C318
C319
C320
C321
1-162-923-11
1-104-913-11
1-162-792-11
1-107-826-11
1-124-779-00
CERAMIC CHIP
TANTAL. CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
47PF
10uF
100PF
0.1uF
10uF
5%
20%
5%
10%
20%
50V
16V
50V
16V
16V
C26
C49
C51
C100
C108
1-126-204-11
1-107-826-11
1-163-038-00
1-126-601-11
1-126-601-11
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
ELECT CHIP
47uF
0.1uF
0.1uF
2.2uF
2.2uF
20%
10%
C322
C323
C324
C326
C327
1-162-970-11
1-163-038-00
1-109-982-11
1-164-004-11
1-115-156-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.1uF
1uF
0.1uF
1uF
10%
20%
20%
16V
16V
25V
50V
50V
25V
25V
10V
25V
10V
C109
C111
C112
C113
C114
1-109-982-11
1-107-752-11
1-126-603-11
1-126-603-11
1-124-779-00
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
ELECT CHIP
ELECT CHIP
1uF
0.1uF
4.7uF
4.7uF
10uF
10%
10%
20%
20%
20%
10V
16V
35V
35V
16V
C328
C651
C652
C653
C654
1-163-021-11
1-163-009-11
1-162-919-11
1-162-919-11
1-163-038-00
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.001uF
22PF
22PF
0.1uF
10%
10%
5%
5%
50V
50V
50V
50V
25V
C115
C116
C117
C118
C119
1-162-970-11
1-162-927-11
1-162-927-11
1-164-299-11
1-164-299-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
100PF
100PF
0.22uF
0.22uF
10%
5%
5%
10%
10%
25V
50V
50V
25V
25V
C655
C657
C658
C659
C660
1-163-251-11
1-107-826-11
1-107-826-11
1-107-826-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100PF
0.1uF
0.1uF
0.1uF
0.1uF
5%
10%
10%
10%
10%
50V
16V
16V
16V
16V
C120
C121
C122
C124
C126
1-124-779-00
1-104-329-11
1-162-927-11
1-162-927-11
1-162-927-11
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
10uF
0.1uF
100PF
100PF
100PF
20%
10%
5%
5%
5%
16V
50V
50V
50V
50V
C661
C700
C701
C702
C703
1-162-964-11
1-107-826-11
1-164-230-11
1-164-315-11
1-162-920-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.001uF
0.1uF
220PF
470PF
27PF
10%
10%
5%
5%
5%
50V
16V
50V
50V
50V
C127
C131
C151
C152
C200
1-107-823-11
1-163-251-11
1-107-725-11
1-164-489-11
1-126-601-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
0.47uF
100PF
0.1uF
0.22uF
0.22uF
10%
5%
10%
10%
10%
16V
50V
16V
16V
16V
C704
C705
C706
C707
C708
1-162-919-11
1-162-970-11
1-162-919-11
1-162-919-11
1-164-156-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
22PF
0.01uF
22PF
22PF
0.1uF
5%
10%
5%
5%
50V
25V
50V
50V
25V
C204
C205
C207
C208
C209
1-126-601-11
1-109-982-11
1-126-603-11
1-126-603-11
1-162-927-11
ELECT CHIP
CERAMIC CHIP
ELECT CHIP
ELECT CHIP
CERAMIC CHIP
2.2uF
1uF
4.7uF
4.7uF
100PF
20%
10%
20%
20%
5%
50V
10V
35V
35V
50V
C709
C710
C711
C712
C713
1-164-156-11
1-124-779-00
1-163-133-00
1-163-133-00
1-163-021-11
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
10uF
470PF
470PF
0.01uF
C210
C211
C212
C213
C214
1-162-927-11
1-164-299-11
1-164-299-11
1-162-927-11
1-162-927-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100PF
0.22uF
0.22uF
100PF
100PF
5%
10%
10%
5%
5%
50V
25V
25V
50V
50V
C714
C717
C718
C719
C720
1-162-964-11
1-126-206-11
1-126-206-11
1-125-565-11
1-164-156-11
CERAMIC CHIP
ELECT CHIP
ELECT CHIP
DOUBLE LAYERS
CERAMIC CHIP
0.001uF
100uF
100uF
0.22F
0.1uF
C215
C231
C251
C301
1-162-927-11
1-163-251-11
1-107-725-11
1-124-779-00
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
100PF
100PF
0.1uF
10uF
5%
5%
10%
20%
50V
50V
16V
16V
C721
C722
C723
1-164-505-11 CERAMIC CHIP
1-126-395-11 ELECT
1-164-346-11 CERAMIC CHIP
66
Remark
10%
5%
10%
20%
10%
20%
Ref. No.
Remark
2.2uF
22uF
1uF
10%
10%
20%
5%
5%
10%
10%
20%
20%
20%
25V
16V
50V
50V
50V
50V
6.3V
6.3V
5.5V
25V
16V
16V
16V
MAIN
Ref. No.
Part No.
Description
C724
C725
C726
C780
C802
1-107-826-11
1-117-681-11
1-109-982-11
1-163-038-00
1-107-725-11
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
100uF
1uF
0.1uF
0.1uF
10%
20%
10%
Remark
C803
C820
C821
C822
C823
1-107-725-11
1-115-772-31
1-104-329-11
1-164-156-11
1-124-779-00
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
0.1uF
5600uF
0.1uF
0.1uF
10uF
10%
20%
10%
C824
C825
C826
C827
C828
1-124-779-00
1-104-329-11
1-124-779-00
1-104-329-11
1-124-779-00
ELECT CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
ELECT CHIP
C829
C830
C831
C832
C833
1-124-779-00
1-124-779-00
1-164-156-11
1-162-970-11
1-162-970-11
C834
C836
C837
C838
C839
10%
16V
16V
10V
25V
16V
Ref. No.
CN700
CN821
CN823
CNJ780
CNP820
Part No.
Description
1-794-364-11
1-750-862-21
1-573-355-11
1-580-907-31
1-793-277-11
CONNECTOR (PLUG) 16P
PIN, CONNECTOR (PC BOARD) 5P
CONNECTOR, FFC/FPC 15P
PLUG, CONNECTOR (BUS CONTROL IN)
PLUG, CONNECTOR 16P
Remark
< JACK >
CNP101 1-774-700-11 JACK, PIN 6P (BUS AUDIO IN, AUDIO OUT)
20%
16V
16V
50V
25V
16V
10uF
0.1uF
10uF
0.1uF
10uF
20%
10%
20%
10%
20%
16V
50V
16V
50V
16V
D1
D100
D101
D102
D103
8-719-422-16
8-719-079-29
8-719-079-29
8-719-079-29
8-719-079-29
DIODE
DIODE
DIODE
DIODE
DIODE
MA8039-L-TX
PTZ-TE25-22B
PTZ-TE25-22B
PTZ-TE25-22B
PTZ-TE25-22B
ELECT CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
10uF
10uF
0.1uF
0.01uF
0.01uF
20%
20%
10%
10%
16V
16V
25V
25V
25V
D200
D201
D202
D203
D650
8-719-079-29
8-719-079-29
8-719-079-29
8-719-079-29
8-719-073-01
DIODE
DIODE
DIODE
DIODE
DIODE
PTZ-TE25-22B
PTZ-TE25-22B
PTZ-TE25-22B
PTZ-TE25-22B
MA111-TX
1-126-204-11
1-117-681-11
1-117-681-11
1-164-816-11
1-115-416-11
ELECT CHIP
ELECT CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
47uF
100uF
100uF
220PF
1000PF
20%
20%
20%
2%
5%
16V
16V
16V
50V
25V
D700
D701
D702
D714
D716
8-719-914-44
8-719-420-14
8-719-073-01
8-719-057-80
8-719-914-44
DIODE
DIODE
DIODE
DIODE
DIODE
DAP202K-T-146
MA8082-M(TX)
MA111-TX
MA8180-M-TX
DAP202K-T-146
C840
C841
C842
C843
C844
1-162-959-11
1-107-826-11
1-115-416-11
1-162-959-11
1-109-982-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
330PF
0.1uF
1000PF
330PF
1uF
5%
10%
5%
5%
10%
50V
16V
25V
50V
10V
D717
D718
D719
D721
D722
8-719-977-12
8-719-073-01
8-719-977-12
8-719-914-43
8-719-073-01
DIODE
DIODE
DIODE
DIODE
DIODE
MA8068-M-TX
MA111-TX
MA8068-M-TX
DAN202K-T-146
MA111-TX
C845
C846
C847
C848
C849
1-107-826-11
1-162-923-11
1-164-156-11
1-135-993-11
1-165-112-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
TANTAL. CHIP
CERAMIC CHIP
0.1uF
47PF
0.1uF
33uF
0.33uF
10%
5%
16V
50V
25V
10V
16V
D723
D780
D781
D782
D783
8-719-422-16
8-719-073-01
8-719-017-62
8-719-017-62
8-719-022-90
DIODE
DIODE
DIODE
DIODE
DIODE
MA8039-L-TX
MA111-TX
MA8068-L-TX
MA8068-L-TX
MA8160-M-TX
C851
C852
C854
C856
C857
1-164-156-11
1-135-993-11
1-164-156-11
1-164-156-11
1-104-851-11
CERAMIC CHIP
TANTAL. CHIP
CERAMIC CHIP
CERAMIC CHIP
TANTAL. CHIP
0.1uF
33uF
0.1uF
0.1uF
10uF
25V
10V
25V
25V
10V
D784
D785
D786
D787
D788
8-719-022-90
8-719-073-01
8-719-073-01
8-719-022-90
8-719-914-43
DIODE
DIODE
DIODE
DIODE
DIODE
MA8160-M-TX
MA111-TX
MA111-TX
MA8160-M-TX
DAN202K-T-146
C858
C859
C860
C861
C862
1-164-156-11
1-107-826-11
1-164-156-11
1-124-779-00
1-124-779-00
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
ELECT CHIP
0.1uF
0.1uF
0.1uF
10uF
10uF
25V
16V
25V
16V
16V
D789
D820
D821
D822
D824
8-719-073-01
8-719-049-38
8-719-420-51
8-719-053-18
8-719-053-18
DIODE
DIODE
DIODE
DIODE
DIODE
MA111-TX
1N5404TU
MA729-TX
1SR154-400TE-25
1SR154-400TE-25
C863
C864
C867
C868
C869
1-107-826-11
1-104-913-11
1-163-038-00
1-126-395-11
1-163-038-00
CERAMIC CHIP
TANTAL. CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
0.1uF
10uF
0.1uF
22uF
0.1uF
16V
16V
25V
16V
25V
D825
D826
D827
D828
D829
8-719-053-18
8-719-057-80
8-719-977-12
8-719-073-01
8-719-420-51
DIODE
DIODE
DIODE
DIODE
DIODE
1SR154-400TE-25
MA8180-M-TX
MA8068-M-TX
MA111-TX
MA729-TX
D830
D831
D832
8-719-053-18 DIODE 1SR154-400TE-25
8-719-053-18 DIODE 1SR154-400TE-25
8-719-977-12 DIODE MA8068-M-TX
20%
10%
20%
20%
10%
20%
20%
< CONNECTOR >
CN100
1-794-513-21 CONNECTOR, FFC/FPC (ZIF) 35P
< DIODE >
67
MAIN
Ref. No.
Part No.
Description
Part No.
Description
D833
D834
D835
D836
D837
8-719-420-51
8-719-420-51
8-719-976-96
8-719-055-30
8-719-055-30
DIODE
DIODE
DIODE
DIODE
DIODE
MA729-TX
MA729-TX
MA8047-H-TX
D1FS4A-TA
D1FS4A-TA
Remark
Ref. No.
Q103
Q201
Q300
Q651
Q700
8-729-047-71
8-729-047-71
8-729-900-53
8-729-020-67
1-801-806-11
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
FMG12-T-148
FMG12-T-148
DTC114EKA-T146
XN1A312-TX
DTC144EK-T146
Remark
D838
D839
D840
D841
8-719-423-35
8-719-423-21
8-719-914-43
8-719-423-15
DIODE
DIODE
DIODE
DIODE
MA8120-H-TX
MA8110-L-TX
DAN202K-T-146
MA8110-H-TX
Q701
Q702
Q703
Q704
Q705
8-729-120-28
8-729-924-73
8-729-020-67
8-729-020-67
8-729-026-49
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC2412K-T-146-QR
FMA9-T1
XN1A312-TX
XN1A312-TX
2SA1037AK-T146-QR
Q780
Q781
Q782
Q783
Q784
8-729-027-23
8-729-900-53
8-729-120-28
8-729-120-28
8-729-027-23
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTA114EKA-T146
DTC114EKA-T146
2SC2412K-T-146-QR
2SC2412K-T-146-QR
DTA114EKA-T146
Q821
Q822
Q823
Q824
Q825
8-729-019-00
8-729-120-28
8-729-822-84
8-729-900-53
8-729-020-67
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SD2394-G
2SC2412K-T-146-QR
2SB1202FAT-TL
DTC114EKA-T146
XN1A312-TX
Q826
Q827
Q828
Q829
Q830
8-729-900-53
8-729-822-84
8-729-106-60
8-729-900-53
8-729-822-84
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTC114EKA-T146
2SB1202FAT-TL
2SB1132-T101-QR
DTC114EKA-T146
2SB1202FAT-TL
Q831
Q832
Q833
Q834
Q835
8-729-020-67
8-729-807-12
8-729-920-85
8-729-020-67
8-729-019-00
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
XN1A312-TX
2SD1802FAT-TL
2SD1664-T101-QR
XN1A312-TX
2SD2394-G
Q836
8-729-020-67 TRANSISTOR XN1A312-TX
< FERRITE BEAD >
FB301
FB302
FB303
FB304
FB601
1-414-235-11
1-414-235-11
1-414-235-11
1-414-230-11
1-414-595-11
FERRITE BEAD INDUCTOR
FERRITE BEAD INDUCTOR
FERRITE BEAD INDUCTOR
FERRITE BEAD INDUCTOR
FERRITE BEAD INDUCTOR
< IC >
IC102
IC104
IC280
IC284
IC300
8-759-653-27
8-759-663-88
8-759-661-47
8-719-679-07
8-759-667-88
IC
IC
IC
IC
IC
TDA7402TR
TA8268H
BA4908-V3
NJM2370U05-TE2
AK4523VF-E2
IC301
IC650
IC651
IC652
IC700
8-759-096-87
8-759-681-72
8-759-277-63
8-759-392-22
8-759-679-62
IC
IC
IC
IC
IC
TC7WU04FU(TE12R)
HD6432355A18F
TC7W14FU(TE12R)
BA3834F
MB90574PMT-G-258-BND
IC701
IC702
IC780
IC801
IC802
8-759-363-81
8-759-495-76
8-759-449-89
8-759-990-43
8-759-460-72
IC
IC
IC
IC
IC
XC61AN4002PR
RN5VD33AA-TL
BA8270F-E2
TL1451ACDB-E20
BA033FP-E2
< RESISTOR >
< JACK >
J1
J700
1-785-503-11 JACK (ANT)
1-566-822-41 JACK (REMOTE IN)
< COIL >
R1
R2
R3
R4
R5
1-216-864-11
1-216-841-11
1-216-825-11
1-216-839-11
1-216-864-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
47K
2.2K
33K
0
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
L280
L281
L286
L650
L700
1-419-476-11
1-412-058-11
1-412-055-11
1-412-064-11
1-412-058-11
250uH
10uH
3.3uH
100uH
10uH
R6
R7
R8
R11
R12
1-216-821-11
1-216-295-00
1-216-864-11
1-216-809-11
1-216-809-11
METAL CHIP
SHORT
METAL CHIP
METAL CHIP
METAL CHIP
1K
0
0
100
100
5%
1/16W
5%
5%
5%
1/16W
1/16W
1/16W
L801
L802
L803
1-414-408-11 INDUCTOR CHIP 1uH
1-469-388-21 INDUCTOR
100uH
1-469-388-21 INDUCTOR
100uH
< TRANSISTOR >
R13
R14
R15
R17
R18
1-216-864-11
1-216-864-11
1-216-864-11
1-216-837-11
1-216-841-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
0
0
22K
47K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
R20
R21
R22
R105
1-216-025-11
1-216-025-11
1-216-295-00
1-216-821-11
RES-CHIP
RES-CHIP
SHORT
METAL CHIP
100
100
0
1K
5%
5%
1/10W
1/10W
5%
1/16W
Q1
Q2
Q3
Q102
68
8-729-920-21
8-729-920-21
8-729-020-67
8-729-047-71
INDUCTOR
INDUCTOR CHIP
INDUCTOR CHIP
INDUCTOR CHIP
INDUCTOR CHIP
DTC314TK-T-146
DTC314TK-T-146
XN1A312-TX
FMG12-T-148
MAIN
Ref. No.
Part No.
Description
Part No.
Description
R110
R111
R112
R113
R114
1-216-033-00
1-216-081-00
1-216-033-00
1-216-081-00
1-216-829-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
220
22K
220
22K
4.7K
5%
5%
5%
5%
5%
Remark
1/10W
1/10W
1/10W
1/10W
1/16W
Ref. No.
R672
R702
R703
R704
R705
1-216-864-11
1-216-809-11
1-216-097-11
1-216-815-11
1-216-025-11
METAL CHIP
METAL CHIP
RES-CHIP
METAL CHIP
RES-CHIP
0
100
100K
330
100
5%
5%
5%
5%
5%
Remark
1/16W
1/16W
1/10W
1/16W
1/10W
R115
R116
R117
R118
R119
1-216-834-11
1-216-829-11
1-216-834-11
1-216-833-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
RES-CHIP
METAL CHIP
12K
4.7K
12K
10K
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R707
R709
R710
R711
R713
1-216-841-11
1-216-809-11
1-216-025-11
1-216-809-11
1-216-864-11
METAL CHIP
METAL CHIP
RES-CHIP
METAL CHIP
METAL CHIP
47K
100
100
100
0
5%
5%
5%
5%
5%
1/16W
1/16W
1/10W
1/16W
1/16W
R205
R210
R211
R212
R213
1-216-821-11
1-216-033-00
1-216-081-00
1-216-033-00
1-216-081-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
220
22K
220
22K
5%
5%
5%
5%
5%
1/16W
1/10W
1/10W
1/10W
1/10W
R714
R715
R716
R717
R718
1-216-025-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-097-11
RES-CHIP
METAL CHIP
METAL CHIP
METAL CHIP
RES-CHIP
100
100
100
100
100K
5%
5%
5%
5%
5%
1/10W
1/16W
1/16W
1/16W
1/10W
R214
R215
R216
R217
R218
1-216-829-11
1-216-834-11
1-216-829-11
1-216-834-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
RES-CHIP
4.7K
12K
4.7K
12K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R719
R720
R721
R722
R723
1-216-025-11
1-216-809-11
1-216-833-11
1-216-809-11
1-216-833-11
RES-CHIP
METAL CHIP
RES-CHIP
METAL CHIP
RES-CHIP
100
100
10K
100
10K
5%
5%
5%
5%
5%
1/10W
1/16W
1/16W
1/16W
1/16W
R219
R300
R302
R303
R307
1-216-809-11
1-216-821-11
1-216-864-11
1-216-864-11
1-216-025-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
RES-CHIP
100
1K
0
0
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/10W
R724
R725
R726
R727
R728
1-216-855-11
1-216-845-11
1-216-845-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
680K
100K
100K
100
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R308
R309
R310
R311
R312
1-216-025-11
1-216-821-11
1-216-825-11
1-216-833-11
1-216-025-11
RES-CHIP
METAL CHIP
METAL CHIP
RES-CHIP
RES-CHIP
100
1K
2.2K
10K
100
5%
5%
5%
5%
5%
1/10W
1/16W
1/16W
1/16W
1/10W
R729
R730
R731
R733
R734
1-216-845-11
1-216-825-11
1-216-845-11
1-216-845-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
2.2K
100K
100K
100K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R313
R314
R315
R316
R601
1-216-308-00
1-216-049-11
1-216-825-11
1-216-857-11
1-216-295-00
METAL CHIP
RES-CHIP
METAL CHIP
METAL CHIP
SHORT
4.7
1K
2.2K
1M
0
5%
5%
5%
5%
1/10W
1/10W
1/16W
1/16W
R735
R736
R737
R738
R739
1-216-057-00
1-216-057-00
1-216-089-11
1-216-089-11
1-216-222-00
METAL CHIP
METAL CHIP
RES-CHIP
RES-CHIP
RES-CHIP
2.2K
2.2K
47K
47K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/8W
R603
R651
R652
R653
R654
1-216-813-11
1-216-845-11
1-216-845-11
1-216-817-11
1-216-813-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
220
100K
100K
470
220
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R740
R741
R742
R743
R744
1-216-025-11
1-216-675-11
1-216-025-11
1-216-675-11
1-216-049-11
RES-CHIP
METAL CHIP
RES-CHIP
METAL CHIP
RES-CHIP
100
10K
100
10K
1K
5%
0.5%
5%
0.5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R655
R656
R660
R661
R662
1-216-864-11
1-216-849-11
1-216-097-11
1-216-825-11
1-216-033-00
METAL CHIP
METAL CHIP
RES-CHIP
METAL CHIP
METAL CHIP
0
220K
100K
2.2K
220
5%
5%
5%
5%
5%
1/16W
1/16W
1/10W
1/16W
1/10W
R745
R746
R747
R748
R749
1-216-049-11
1-216-049-11
1-216-049-11
1-216-049-11
1-216-025-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
1K
1K
1K
1K
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R663
R664
R665
R666
R667
1-216-033-00
1-216-813-11
1-216-845-11
1-216-845-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
220
220
100K
100K
100K
5%
5%
5%
5%
5%
1/10W
1/16W
1/16W
1/16W
1/16W
R750
R751
R752
R753
R754
1-216-049-11
1-216-049-11
1-216-821-11
1-216-845-11
1-216-821-11
RES-CHIP
RES-CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
1K
100K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/16W
1/16W
1/16W
R668
R669
R670
1-216-845-11 METAL CHIP
1-216-833-11 RES-CHIP
1-216-842-11 METAL CHIP
100K
10K
56K
5%
5%
5%
1/16W
1/16W
1/16W
R756
R757
1-216-845-11 METAL CHIP
1-216-025-11 RES-CHIP
100K
100
5%
5%
1/16W
1/10W
69
MAIN
Ref. No.
RELAY
Part No.
Description
Part No.
Description
R758
R759
R760
R761
R762
1-218-716-11
1-216-025-11
1-218-716-11
1-216-821-11
1-216-853-11
METAL CHIP
RES-CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
100
10K
1K
470K
0.5%
5%
0.5%
5%
5%
Remark
1/16W
1/10W
1/16W
1/16W
1/16W
Ref. No.
R856
R857
R858
R859
R860
1-216-033-00
1-216-061-00
1-216-061-00
1-216-061-00
1-218-716-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
220
3.3K
3.3K
3.3K
10K
5%
5%
5%
5%
0.5%
Remark
1/10W
1/10W
1/10W
1/10W
1/16W
R763
R764
R765
R766
R767
1-216-821-11
1-216-821-11
1-216-821-11
1-216-837-11
1-216-847-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
1K
22K
150K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R861
R862
R864
R865
R866
1-218-704-11
1-216-190-00
1-216-845-11
1-216-295-00
1-216-049-11
METAL CHIP
RES-CHIP
METAL CHIP
SHORT
RES-CHIP
3.3K
470
100K
0
1K
0.5%
5%
5%
1/16W
1/8W
1/16W
5%
1/10W
R768
R769
R770
R771
R780
1-216-833-11
1-216-864-11
1-216-845-11
1-216-845-11
1-216-833-11
RES-CHIP
METAL CHIP
METAL CHIP
METAL CHIP
RES-CHIP
10K
0
100K
100K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R867
R869
1-216-041-00 METAL CHIP
1-216-295-00 SHORT
5%
1/10W
R781
R782
R783
R784
R785
1-216-809-11
1-216-089-11
1-216-097-11
1-216-089-11
1-216-097-11
METAL CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
100
47K
100K
47K
100K
5%
5%
5%
5%
5%
1/16W
1/10W
1/10W
1/10W
1/10W
R786
R787
R802
R803
R805
1-216-150-11
1-216-841-11
1-216-025-11
1-216-821-11
1-216-864-11
RES-CHIP
METAL CHIP
RES-CHIP
METAL CHIP
METAL CHIP
10
47K
100
1K
0
5%
5%
5%
5%
5%
1/8W
1/16W
1/10W
1/16W
1/16W
R821
R822
R823
R824
R826
1-216-073-00
1-216-198-00
1-216-825-11
1-216-833-11
1-216-839-11
METAL CHIP
RES-CHIP
METAL CHIP
RES-CHIP
METAL CHIP
10K
1K
2.2K
10K
33K
5%
5%
5%
5%
5%
1/10W
1/8W
1/16W
1/16W
1/16W
R827
R828
R829
R830
R831
1-216-833-11
1-216-833-11
1-216-845-11
1-216-833-11
1-216-057-00
RES-CHIP
RES-CHIP
METAL CHIP
RES-CHIP
METAL CHIP
10K
10K
100K
10K
2.2K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/10W
R832
R833
R834
R835
R836
1-218-716-11
1-218-732-11
1-216-835-11
1-216-835-11
1-216-839-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
47K
15K
15K
33K
0.5%
0.5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R837
R838
R839
R840
R841
1-216-839-11
1-216-839-11
1-216-839-11
1-216-845-11
1-216-829-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
33K
33K
33K
100K
4.7K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R842
R843
R844
R845
R846
1-216-033-00
1-216-061-00
1-216-061-00
1-216-061-00
1-218-716-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
220
3.3K
3.3K
3.3K
10K
5%
5%
5%
5%
0.5%
1/10W
1/10W
1/10W
1/10W
1/16W
R847
R850
R851
R852
R853
1-218-704-11
1-216-073-00
1-216-029-00
1-216-182-00
1-216-190-00
METAL CHIP
METAL CHIP
METAL CHIP
RES-CHIP
RES-CHIP
3.3K
10K
150
220
470
0.5%
5%
5%
5%
5%
1/16W
1/10W
1/10W
1/8W
1/8W
470
0
< NETWORK RESISTOR >
RB700
1-233-576-11 RES, CHIP NETWORK
100
< SWITCH >
S700
1-571-754-31 SWITCH, PUSH (1 KEY) (NOSE DET)
< TUNER >
TU1
< THERMISTOR (POSITIVE) >
TH780
70
A-3220-738-A TUNER UNIT (TUX-020)
1-801-792-21 THERMISTOR, POSITIVE
< VIBRATOR >
X300
1-781-905-21 VIBRATOR, CRYSTAL (22.5792MHz)
X650
1-781-565-11 VIBRATOR, CRYSTAL (18.432MHz)
X700
1-760-928-21 VIBRATOR, CRYSTAL (32.768kHz)
X701
1-781-907-21 VIBRATOR, CRYSTAL (3.6864MHz)
*************************************************************
1-678-397-11 RELAY BOARD
************
*
< CONNECTOR >
CN800
CN801
* CN802
1-794-064-11 SOCKET, CONNECTOR 14P
1-794-363-11 CONNECTOR (RECEPTACLE) 16P
1-569-775-21 PIN, CONNECTOR (SMD) 5P
< DIODE >
D800
D801
D802
D803
D804
8-719-977-12
8-719-977-12
8-719-057-80
8-719-977-12
8-719-977-12
DIODE
DIODE
DIODE
DIODE
DIODE
MA8068-M-TX
MA8068-M-TX
MA8180-M-TX
MA8068-M-TX
MA8068-M-TX
D805
D806
D807
D808
D809
8-719-977-12
8-719-977-12
8-719-977-12
8-719-977-12
8-719-977-12
DIODE
DIODE
DIODE
DIODE
DIODE
MA8068-M-TX
MA8068-M-TX
MA8068-M-TX
MA8068-M-TX
MA8068-M-TX
D810
D811
8-719-977-12 DIODE MA8068-M-TX
8-719-977-12 DIODE MA8068-M-TX
RELAY
Ref. No.
Part No.
Description
Remark
< DIODE >
LED800 8-719-077-75 LED BR1101F-TR (DISC IN)
< SWITCH >
LSW800 1-771-883-11 SWITCH, TACTILE (WITH LED) (Z)
< RESISTOR >
R800
1-216-041-00 METAL CHIP
470
5%
1/10W
< SWITCH >
S800
1-572-921-11 SWITCH, KEY BOARD (RESET)
*************************************************************
A-3317-305-A SENSOR BOARD, COMPLETE
************************
< CAPACITOR >
C553
C554
C555
C556
C557
1-107-826-11
1-107-826-11
1-107-826-11
1-107-826-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
10%
10%
10%
10%
10%
16V
16V
16V
16V
16V
C558
C559
1-107-826-11 CERAMIC CHIP
1-107-826-11 CERAMIC CHIP
0.1uF
0.1uF
10%
10%
16V
16V
< CONNECTOR >
CN550
* CN551
CN552
1-691-381-11 CONNECTOR, FFC/FPC 17P
1-770-619-11 PIN, CONNECTOR 2P
1-770-619-41 PIN, CONNECTOR 2P
< SWITCH >
SW550
SW551
SW552
SW553
SW554
1-572-467-61 SWITCH, PUSH (1 KEY) (LIMIT IN)
1-771-606-21 SWITCH, 2P PUSH (2 KEY) (PROTECT,
REFLECT)
1-572-688-11 SWITCH, PUSH (1 KEY) (DISC IN)
1-692-849-21 SWITCH, PUSH (1 KEY) (PACK IN)
1-572-288-21 SWITCH, PUSH (REC-P)
SW555 1-572-688-11 SWITCH, PUSH (1 KEY) (PLAY-P)
*************************************************************
A-3326-079-A SERVO MOUNTED BOARD, COMPLETE
********************************
*
< CAPACITOR >
Ref. No.
SENSOR
SERVO
Part No.
Description
C410
C411
C414
C415
C416
1-107-826-11
1-107-826-11
1-162-970-11
1-107-823-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.01uF
0.47uF
0.1uF
10%
10%
10%
10%
10%
16V
16V
25V
16V
16V
C417
C418
C419
C420
C423
1-162-927-11
1-162-968-11
1-107-823-11
1-164-245-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100PF
0.0047uF
0.47uF
0.015uF
0.1uF
5%
10%
10%
10%
10%
50V
50V
16V
25V
16V
C424
C425
C426
C428
C429
1-109-982-11
1-107-826-11
1-107-826-11
1-107-826-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
1uF
0.1uF
0.1uF
0.1uF
0.1uF
10%
10%
10%
10%
10%
10V
16V
16V
16V
16V
C440
C441
C443
C444
C445
1-104-852-11
1-162-970-11
1-162-970-11
1-162-970-11
1-164-227-11
TANTAL. CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
22uF
0.01uF
0.01uF
0.01uF
0.022uF
20%
10%
10%
10%
10%
10V
25V
25V
25V
25V
C446
C447
C450
C452
C453
1-162-964-11
1-162-969-11
1-164-677-11
1-110-563-11
1-162-968-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.001uF
0.0068uF
0.033uF
0.068uF
0.0047uF
10%
10%
10%
10%
10%
50V
25V
16V
16V
50V
C454
C457
C458
C459
C460
1-107-682-11
1-162-966-11
1-164-227-11
1-162-970-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
1uF
0.0022uF
0.022uF
0.01uF
0.1uF
10%
10%
10%
10%
10%
16V
50V
25V
25V
16V
C462
C467
C469
C470
C471
1-104-851-11
1-115-339-11
1-115-339-11
1-115-339-11
1-104-852-11
TANTAL. CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
TANTAL. CHIP
10uF
0.1uF
0.1uF
0.1uF
22uF
20%
10%
10%
10%
20%
10V
50V
50V
50V
10V
C472
C473
C474
C475
C510
1-162-970-11
1-107-826-11
1-107-826-11
1-104-851-11
1-164-611-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
TANTAL. CHIP
CERAMIC CHIP
0.01uF
0.1uF
0.1uF
10uF
0.001uF
10%
10%
10%
20%
10%
25V
16V
16V
10V
500V
C511
C513
C516
C517
C520
1-107-836-11
1-107-826-11
1-107-826-11
1-104-913-11
1-107-826-11
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
TANTAL. CHIP
CERAMIC CHIP
22uF
0.1uF
0.1uF
10uF
0.1uF
20%
10%
10%
20%
10%
8V
16V
16V
16V
16V
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
TANTAL. CHIP
0.1uF
0.01uF
0.1uF
0.1uF
22uF
10%
10%
10%
10%
20%
16V
25V
16V
16V
16V
0.1uF
0.1uF
10%
10%
16V
16V
C400
C401
C402
C403
C404
1-162-970-11
1-104-852-11
1-162-927-11
1-162-927-11
1-162-927-11
CERAMIC CHIP
TANTAL. CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
22uF
100PF
100PF
100PF
10%
20%
5%
5%
5%
25V
10V
50V
50V
50V
C524
C527
C528
C529
C530
1-107-826-11
1-162-970-11
1-107-826-11
1-107-826-11
1-119-751-11
C406
C407
C408
1-162-970-11 CERAMIC CHIP
1-107-826-11 CERAMIC CHIP
1-107-826-11 CERAMIC CHIP
0.01uF
0.1uF
0.1uF
10%
10%
10%
25V
16V
16V
C533
C534
1-107-826-11 CERAMIC CHIP
1-107-826-11 CERAMIC CHIP
Remark
71
SERVO
Ref. No.
Part No.
Description
Remark
Ref. No.
Part No.
< CONNECTOR >
CN400
CN401
CN440
CN510
CN520
D440
D441
D510
D511
D520
1-785-771-21
1-774-930-21
1-573-361-11
1-691-372-21
1-691-381-11
8-719-988-61
8-719-988-61
8-719-046-86
8-719-046-86
8-719-420-14
R400
R401
R402
R403
R404
1-216-809-11
1-216-833-11
1-216-845-11
1-216-855-11
1-216-809-11
METAL CHIP
RES-CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
10K
100K
680K
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
< DIODE >
R408
R409
R411
R412
R413
1-216-827-11
1-216-821-11
1-216-821-11
1-216-811-11
1-216-819-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
3.3K
1K
1K
150
680
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R414
R415
R416
R420
R421
1-216-853-11
1-216-829-11
1-216-829-11
1-216-809-11
1-216-857-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
470K
4.7K
4.7K
100
1M
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R440
R441
R442
R443
R444
1-218-704-11
1-218-708-11
1-216-065-11
1-216-065-11
1-216-073-00
METAL CHIP
METAL CHIP
RES-CHIP
RES-CHIP
METAL CHIP
3.3K
4.7K
4.7K
4.7K
10K
0.5%
0.5%
5%
5%
5%
1/16W
1/16W
1/10W
1/10W
1/10W
R446
R447
R448
R449
R450
1-218-700-11
1-218-700-11
1-216-864-11
1-216-864-11
1-216-853-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
2.2K
0
0
470K
0.5%
0.5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R451
R452
R453
R454
R455
1-218-700-11
1-216-833-11
1-216-864-11
1-216-845-11
1-216-827-11
METAL CHIP
RES-CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
10K
0
100K
3.3K
0.5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R456
R457
R458
R459
R460
1-216-833-11
1-216-827-11
1-216-833-11
1-216-845-11
1-216-833-11
RES-CHIP
METAL CHIP
RES-CHIP
METAL CHIP
RES-CHIP
10K
3.3K
10K
100K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R461
R462
R463
R464
R465
1-216-833-11
1-216-841-11
1-216-809-11
1-216-864-11
1-216-819-11
RES-CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
47K
100
0
680
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R466
R467
R469
R470
R471
1-216-864-11
1-216-815-11
1-216-864-11
1-216-864-11
1-218-688-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
330
0
0
680
5%
5%
5%
5%
0.5%
1/16W
1/16W
1/16W
1/16W
1/16W
R472
R473
R474
R476
R478
1-216-829-11
1-216-097-11
1-219-724-11
1-220-149-11
1-216-065-11
METAL CHIP
RES-CHIP
METAL CHIP
REGISTER
RES-CHIP
4.7K
100K
1
2.2
4.7K
5%
5%
1%
10%
5%
1/16W
1/10W
1/4W
1/2W
1/10W
R479
1-216-853-11 METAL CHIP
470K
5%
1/16W
DIODE
DIODE
DIODE
DIODE
DIODE
1SS355TE-17
1SS355TE-17
F1J6TP
F1J6TP
MA8082-M (TX)
1-414-235-22 FERRITE BEAD INDUCTOR
1-414-235-22 FERRITE BEAD INDUCTOR
< IC >
IC400
IC401
IC402
IC403
IC440
8-752-384-47
8-759-538-44
8-759-661-26
8-759-096-87
8-752-080-95
IC
IC
IC
IC
IC
IC442
IC510
IC520
IC521
8-729-903-10
8-759-523-48
8-759-430-25
8-759-040-83
TRANSISTOR FMW1-T-148
IC TC74ACT540FT(EL)
IC BH6511FS-E2
IC BA6287F-T1
CXD2652AR
MSM51V17400D-10TK-FS
AT24C16N-10SI-TR
TC7WU04FU(TE12R)
CXA2523AR
< COIL >
L400
L401
L440
L442
L443
1-412-058-11
1-500-245-11
1-412-058-11
1-414-234-22
1-414-234-22
L444
1-414-234-22 FERRITE BEAD INDUCTOR
INDUCTOR CHIP 10uH
FERRITE BEAD INDUCTOR
INDUCTOR CHIP 10uH
FERRITE BEAD INDUCTOR
FERRITE BEAD INDUCTOR
< TRANSISTOR >
Q400
Q440
Q441
Q442
Q443
8-729-230-49
8-729-900-53
8-729-106-60
8-729-028-91
8-729-101-07
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
Q444
Q445
Q446
Q447
Q510
8-729-028-91
8-729-028-99
8-729-028-99
8-729-026-53
8-729-042-92
TRANSISTOR DTA144EUA-T106
TRANSISTOR DTC114YUA-T106
TRANSISTOR DTC114YUA-T106
TRANSISTOR 2SA1576A-T106-QR
FET 2SK1470-TD
Q511
Q512
Q520
8-729-042-91 FET 2SJ190-TD
8-729-028-96 TRANSISTOR DTC114EUT106
8-729-120-28 TRANSISTOR 2SC2412K-T-146-QR
72
Remark
< RESISTOR >
CONNECTOR, FFC/FPC (ZIF) 35P
CONNECTOR, FFC/FPC 51P
CONNECTOR, FFC/FPC 21P
CONNECTOR, FFC/FPC 8P
CONNECTOR, FFC/FPC 17P
< FERRITE BEAD >
FB443
FB444
Description
2SC2712Y-TE85L
DTC114EKA-T146
2SB1132-T101-QR
DTA144EUA-T106
2SB798-T1DK
SERVO
Ref. No.
Part No.
Description
R480
R482
R483
R484
R485
1-216-863-11
1-216-821-11
1-216-821-11
1-216-841-11
1-216-821-11
RES-CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
3.3M
1K
1K
47K
1K
5%
5%
5%
5%
5%
Remark
1/16W
1/16W
1/16W
1/16W
1/16W
R486
R487
R512
R513
R516
1-216-833-11
1-216-864-11
1-216-089-11
1-216-089-11
1-216-833-11
RES-CHIP
METAL CHIP
RES-CHIP
RES-CHIP
RES-CHIP
10K
0
47K
47K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/10W
1/10W
1/16W
R517
R520
R521
R522
R523
1-216-295-00
1-216-295-00
1-216-295-00
1-216-295-00
1-216-295-00
SHORT
SHORT
SHORT
SHORT
SHORT
0
0
0
0
0
R524
1-216-057-00 METAL CHIP
2.2K
Ref. No.
Remark
#1
#2
#3
#4
#5
7-685-792-09
7-621-255-35
7-621-772-20
7-627-553-28
7-685-106-19
SCREW +PTT 2.6X6 (S)
SCREW +P 2X5
SCREW +B 2X5
SCREW, PRECISION +P 2X2.5
SCREW +P 2X10 TYPE2 NON-SLIT
#6
#7
#8
#9
#10
7-685-753-09
7-685-794-09
7-627-852-37
7-627-553-37
7-628-253-00
SCREW +PTT 3X10 (S)
SCREW +PTT 2.6X10 (S)
SCREW, PRECISION +P 1.7X1.8 TYPE3
SCREW, PRECISION +P 2X3 TYPE3
SCREW +PS 2X4
#11
7-621-555-10 SCREW +K 2X3
*************************************************************
5%
1/10W
RB400 1-233-576-11 RES, CHIP NETWORK 100
RB402 1-233-576-11 RES, CHIP NETWORK 100
RB403 1-239-419-11 NETWORK RESISTOR (CHIP) 470
RB404 1-233-576-11 RES, CHIP NETWORK 100
RB405 1-233-576-11 RES, CHIP NETWORK 100
*************************************************************
MISCELLANEOUS
***************
210
219
221
222
F901
Description
**************
HARDWARE LIST
**************
PARTS FOR INSTALLATION AND CONNECTIONS
***************************************
< NETWORK RESISTOR >
11
13
14
159
0 207
Part No.
1-790-926-21
1-791-560-11
1-792-861-11
1-790-418-11
8-583-057-02
CORD (WITH CONNECTOR) (POWER)
CABLE, SHIELD FLEXIBLE FLAT
CABLE, FLEXIBLE FLAT
MICRO COMPUTER FLEXIBLE BOARD
PICK-UP, OPTICAL KMS-263A/J1N
1-790-417-11
1-790-416-11
1-790-434-11
1-500-412-21
1-532-877-11
OP FLEXIBLE BOARD
SENSOR FLEXIBLE BOARD
OWH FLEXIBLE BOARD
HEAD, OVER WRITE (RF325-74A)
FUSE (BLADE TYPE) (AUTO FUSE) 10A
M501
X-3376-526-1 MOTOR ASSY, SLED (SLED)
M502
X-3376-525-1 MOTOR ASSY, LOADING (LOADING)
M503
A-3301-942-A MOTOR ASSY, SPINDLE (SPINDLE)
*************************************************************
301
302
303
304
305
X-3373-602-1
3-924-961-01
X-3368-725-1
7-682-160-01
3-040-979-02
FRAME ASSY
SUPPORT (ND), FITTING
SCREW ASSY, FITTING
SCREW +P 4X6
COLLAR
306
307
308
309
310
3-027-138-01
3-934-325-01
1-790-926-21
X-3379-045-1
7-621-284-20
SPRING, FITTING
SCREW, +K (5X8) TAPPING
CORD (WITH CONNECTOR) (POWER)
BRACKET (OPT) ASSY
SCREW +P 2.6X6
301
302
303
304
305
306
309
310
307
308
ACCESSORIES & PACKING MATERIALS
********************************
3-048-177-11 MANUAL, INSTRUCTION (ENGLISH,FRENCH,
SPANISH)
3-048-178-11 MANUAL, INSTRUCTION, INSTALL (ENGLISH,
FRENCH,SPANISH)
X-3378-490-1 CASE (PANEL) ASSY (for FRONT PANEL)
*************************************************************
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
Les composants identifiés par une
marque 0 sont critiques pour la
sécurité.
Ne les remplacer que par une piéce
portant le numéro spécifié.
73
MDX-C800REC
9-870-144-31
Sony Corporation
Mobile Electronics Division Company
74
2000C0416-1
Printed in Japan ©2000. 3
Published by General Engineering Dept.