Download IC-M32 SERVICE MANUAL - R

VHF MARINE TRANSCEIVER
iC-m32
INTRODUCTION
This service manual describes the latest service information
for the IC-M32 VHF MARINE TRANSCEIVER at the time of
publication.
To upgrade quality, all electrical or mechanical parts and
internal circuits are subject to change without notice or obligation.
Model
Version
U.S.A.
IC-M32
Symbol AC adapter TX high power
[USA]
BC-147A
S.E. Asia
[SEA]
BC-147E
Australia
[AUS]
BM-95V
5W
DANGER
NEVER connect the transceiver to an AC outlet or to a DC
power supply that uses more than 10 V. This will ruin the
transceiver.
DO NOT expose the transceiver to rain, snow or any liquids.
DO NOT reverse the polarities of the power supply when
connecting the transceiver.
DO NOT apply an RF signal of more than 20 dBm (100mW)
to the antenna connector. This could damage the transceiver’s front end.
ORDERING PARTS
Be sure to include the following four points when ordering
replacement parts:
1.
2.
3.
4.
10-digit order numbers
Component part number and name
Equipment model name and unit name
Quantity required
<SAMPLE ORDER>
1110003200 S.IC TA31136FN
8930060730
2691 keyboard
IC-M32 MAIN UNIT
IC-M32 Chassis
1 piece
5 pieces
Addresses are provided on the inside back cover for your convenience.
REPAIR NOTES
1.
2.
3.
4.
5.
6.
7.
Make sure a problem is internal before disassembling the transceiver.
DO NOT open the transceiver until the transceiver is disconnected from its power source.
DO NOT force any of the variable components. Turn them slowly and smoothly.
DO NOT short any circuits or electronic parts. An insulated turning tool MUST be used for all adjustments.
DO NOT keep power ON for a long time when the transceiver is defective.
DO NOT transmit power into a signal generator or a sweep generator.
ALWAYS connect a 40 dB to 50 dB attenuator between the transceiver and a deviation meter or spectrum analyzer when using
such test equipment.
8. READ the instructions of test equipment thoroughly before connecting equipment to the transceiver.
TABLE OF CONTENTS
SECTION
1
SPECIFICATIONS
SECTION
2
INSIDE VIEWS
SECTION
3
DISASSEMBLY INSTRUCTIONS
SECTION
4
CIRCUIT DESCRIPTION
SECTION
4-1
RECEIVER CIRCUITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-1
4-2
TRANSMITTER CIRCUITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-2
4-3
PLL CIRCUIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-3
4-4
POWER SUPPLY CIRCUITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-3
4-5
CPU PORT ALLOCATIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-4
5
ADJUSTMENT PROCEDURES
5-1
PREPARATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5-1
5-2
PLL AND TRANSMITTER ADJUSTMENTS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5-4
5-3
RECEIVER ADJUSTMENT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5-5
SECTION
6
PARTS LIST
SECTION
7
MECHANICAL PARTS AND DISASSEMBLY
CHASIS PARTS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7-1
CHARGER PARTS (BC-150) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7-3
SECTION
8
SEMI-CONDUCTOR INFORMATION
SECTION
9
BOARD LAYOUTS
SECTION
10 BLOCK DIAGRAM
SECTION
11 VOLTAGE DIAGRAM
SECTION 1 SPECIFICATIONS
‘ GENERAL
• Frequency coverage
: 156.025–157.425 MHz
156.050–163.275 MHz
• Type of emission
: 16K0G3E
• Antenna impedance
: 50 Ω
• MIC impedance
: 2 kΩ
• Audio impedance
:8Ω
• Power supply requirement
: 7.5 V DC (negative ground; supplied battery pack)
• Current drain (approx.)
: Transmit
• Frequency stability
: ±10 ppm
• Usable temperature range
: –20˚C to +60˚C; –4˚F to +140˚F
• Dimensions (projections not included)
: 61(W) × 135(H) × 41(D) mm; 2
• Weight (approx.)
: 360 g; 12.7 oz. (with BP-224)
at High (5.0 W)
at Low (1.0 W)
max audio
Receive
1.5 A
0.7 A
200 mA
13⁄32(W)
× 5 5⁄16(H) × 1 5⁄8(D) in.
‘ TRANSMITTER
• RF output power
(with supplied battery pack)
: 5 W / 1 W (High / Low)
• Modulation system
: Variable reactance frequency modulation
• Maximum frequency deviation
: ±5.0 kHz
• Spurious emissions
: 68 dB
• Adjacent channel power
: 70 dB
• Transmitter audio distortion
: Less than 10 % at 1 kHz, 60% deviation
• Residual modulation
: 40 dB
• Audio frequency response
: +1 dB to –3 dB of 6 dB octave from 300 Hz to 3000 Hz
‘ RECEIVER
• Receive system
: Double conversion superheterodyne system
• Intermediate frequencies
: 1st
2nd
• Sensitivity
: 0.25 µV at 12 dB SINAD (typical)
21.7 MHz
450 kHz
• Squelch sensitivity
: 0.35 µV at threshold
• Adjacent channel selectivity
: 70 dB (typical)
• Spurious response rejection
: 70 dB (typical)
• Intermodulation rejection ratio
: 70 dB (typical)
• Hum and noise
: 40 dB
• Audio output power
: 350 mW typical at 10% distortion with an 8 Ω load
• Audio frequency response
: +1 dB to –3 dB of –6 dB octave from 300 Hz to 3000 Hz
Specifications are measured in accordance with EIA/TIA-603.
All stated specifications are subject to change without notice or obligation.
1-1
‘ VHF MARINE CHANNEL LIST
Channel No.
USA INT CAN
01
01
01A
156.050
160.650
156.050
156.050
Channel No.
USA INT CAN
Frequency (MHz)
Transmit
Receive
21A
157.050
157.050
73
73
73
156.675
156.675
157.100
161.700
74
74
74
156.725
156.725
22A
157.100
157.100
77*
77
77*
156.875
156.875
23
157.150
161.750
156.925
161.525
157.150
157.150
156.925
156.925
156.975
161.575
156.975
156.975
157.025
161.625
157.025
157.025
157.075
161.675
157.075
157.075
157.125
161.725
82A
157.125
157.125
21A
22
Channel No.
USA INT CAN
02
02
156.100
160.700
03
03
156.150
160.750
156.150
156.150
23A
156.200
160.800
24
24
24
157.200
161.800
156.200
156.200
25
25
25
157.250
161.850
156.250
160.850
26
26
26
157.300
161.900
05A
156.250
156.250
27
27
27
157.350
161.950
06
156.300
156.300
28
28
28
157.400
162.000
156.350
160.950
60
60
156.025
160.625
07A
156.350
156.350
61
156.075
160.675
156.075
156.075
156.125
160.725
156.125
156.125
83A
156.175
160.775
84
156.175
156.175
84A
64
156.225
160.825
85
64A
156.225
156.225
85A
03A
04
04A
05
05A
06
06
Frequency (MHz)
Receive
Transmit
07
07A
22A
23
78
78A
79
79A
80A
81
156.400
156.400
09
09
09
156.450
156.450
10
10
10
156.500
156.500
11
11
11
156.550
156.550
12
12
12
156.600
156.600
13*
13
13*
156.650
156.650
14
14
14
156.700
156.700
15*
15*
15*
156.750
156.750
65
156.275
160.875
86
16*
16
16
156.800
156.800
65A 65A 65A
156.275
156.275
86A
17*
17
17*
156.850
156.850
66
156.325
160.925
87
156.900
161.500
66A 66A 66A*
156.325
156.325
87A
156.900
156.900
67*
67
67
156.375
156.375
88
156.950
161.550
68
68
68
156.425
156.425
88A
19A
156.950
156.950
69
69
69
156.475
156.475
20*
157.000
161.600
70
70
70
Rx only
156.525
157.000
157.000
71
71
71
156.575
156.575
157.050
161.650
72
72
72
156.625
156.625
18
18A
18A
19
19A
20
20
20A
21
21
62A
63
63A
64
64A
81A
82
08
62
80A
81A
08
61A
79A
80
08
61A
78A
82A
83
84
85
86
87
88
Frequency (MHz)
Receive
Transmit
83
157.175
161.775
83A
157.175
157.175
84
157.225
161.825
157.225
157.225
157.275
161.875
157.275
157.275
157.325
161.925
157.325
157.325
157.375
161.975
157.375
157.375
157.425
162.025
157.425
157.425
85
86
87
88
* Low power only
NOTE: Channels 3, 21, 23, 61, 64, 81, 82 and 83 CANNOT be used by the general public in USA waters.
‘ WX CHANNEL LIST
Weather
channel
Frequency (MHz)
Transmit
Receive
Weather
channel
Frequency (MHz)
Transmit
Receive
WX01
Receive only
162.550
WX06
Receive only
162.500
WX02
Receive only
162.400
WX07
Receive only
162.525
WX03
Receive only
162.475
WX08
Receive only
161.650
WX04
Receive only
162.425
WX09
Receive only
161.775
WX05
Receive only
162.450
WX10
Receive only
163.275
1-2
SECTION 2
INSIDE VIEWS
• MAIN UNIT
TOP VIEW
BOTTOM VIEW
Antenna switching circuit
(D52: MA77)
Antenna switching circuit
(D90: 1SV307)
APC
(IC50: NJM2125F)
Power amplifier
(Q54: RD07MVS1)
1st mixer
(Q150: 3SK299)
IF detector IC
(IC170: TA31136FN)
IF amplifier
(Q151: 2SC2714 Y)
TX/RX switch
(D50, D51: MA77)
VCO circuit
PLL IC
(IC1: µPD3140GS)
Mic amplifier and
low-pass filter circuits
(IC200: NJM2902V)
D/A converter
(IC190: M62363FP-650C)
CPU
(IC360: M37560M8A-700GP)
EEPROM
(IC340: BR24L16FV)
2-1
SECTION 3
DISASSEMBLY INSTRUCTIONS
¡Removing the Rear panel
¡Removing the Chassis unit
G
A
B
Rear panel
C
E
C
MP31
A
D
B
Chassis unit
F (Speaker connector)
Rubber
Front panel
Front panel
q Unscrew 1 screw, A (2 × 10 mm), and remove 1 washer, B.
w Unscrew 3 screws, C (2 × 8 mm).
e Remove the rear panel and rubber from the front panel.
q
w
e
r
Unscrew 1 nut, D.
Unscrew 2 screws, E (2 × 6 mm).
Take off the chassis unit in the direction of the arrow.
Unplug, F, to separate the front panel, J251, and the
chassis unit.
t Remove 1 washer, G.
NOTE:
A : For IC-M2A only.
B : For IC-M32 only.
¡Removing the MAIN unit
H
NOTE: The chassis panel MP31 is a
common parts for IC-M2A and IC-M32.
Need to screw the MP42 (C) to the B
location for IC-M32.
H
H
MAIN unit
I
Chassis MP31
q Unscrew 7 screws, H (2 × 4 mm).
w Unsolder 3 points, I, and remove earth plate.
e Separate the MAIN unit and the chassis.
3-1
SECTION 4 CIRCUIT DESCRIPTION
4-1-3 2ND IF AND DEMODULATOR CIRCUITS
(MAIN UNIT)
4-1 RECEIVER CIRCUITS
4-1-1 ANTENNA SWITCHING CIRCUIT
(MAIN UNIT)
The 2nd mixer circuit converts the 1st IF signal to a 2nd IF
signal. A double conversion superheterodyne system (which
converts receive signal twice) improves the image rejection
and obtain stable receiver gain.
The antenna switching circuit functions as a low-pass filter
while receiving and as resonator circuit while transmitting.
The circuit does not allow transmit signals to enter receiver
circuits.
The 1st IF signal is applied to a 2nd mixer section of the FM
IF IC (IC170, pin 16). The signal is then mixed with a 2nd LO
signal for conversion into a 450 kHz 2nd IF signal.
Received signals from the antenna connector pass through
the low-pass filter (L81, L82, C83–C86, C89) and antenna
switching circuit (D52, D90). The filtered signals are then
applied to the RF amplifier circuit (Q90).
IC170 contains the 2nd mixer, limiter amplifier, quadrature
detector and active filter circuits. A 21.25 MHz 2nd LO signal
is produced at the PLL circuit using the reference frequency.
4-1-2 RF AND 1ST MIXER CIRCUITS (MAIN UNIT)
The 1st mixer circuit converts the received signals to a fixed
frequency of the 1st IF signal with a PLL output frequency.
By changing the PLL frequency, only the desired frequency
will be passed through a pair of crystal filters at the next
stage of the 1st mixer.
The 2nd IF signal from the 2nd mixer (IC170, pin 3) passes
through ceramic filters (FI170) to remove unwanted heterodyne frequencies. It is then amplified at the limiter amplifier
section (IC170, pin 5) and applied to the quadrature detector section (IC170, pins 10 and 11) to demodulate the 2nd IF
signal into AF signals.
The signals from the antenna switching circuit are passed
through the tunable bandpass filter (D92) and amplified at
the RF amplifier (Q90). The amplified signals are passed
through another tunable bandpass filter (D130), and then
applied to the 1st mixer circuit (Q150).
4-1-4 AF CIRCUIT (MAIN UNIT)
AF signals from the FM IF IC (IC170, pin 9) are fed to the
analog switch (IC260).
The AF signals (detected signals) are passed through the
analog switch (IC260, pins 2 and 1) and are then applied to
the active low-pass filter (IC200c, pin 9).
The filtered signals are mixed at the 1st mixer (Q150) with a
1st LO signal coming from the PLL circuit to produce a 21.7
MHz 1st IF signal. The 1st IF signal is passed through two
crystal filters (FI150, FI151) and is then amplified at the IF
amplifier (Q151).
The filtered AF signals are applied to and adjusted audio
level at the D/A convertor (IC190, pin 24) to adjust amplitude. The level controlled signals are passed through the AF
mute switch (Q280) which is controlled by “AFMS” signal
from the CPU (IC360, pin 47). The passed signals are
applied to the AF power amplifier (IC280, pin 4), and then
output to the internal speaker or [EXT SP] jack after being
passed through the de-emphasis circuit (R286, C285) to
obtain the –6 dB/octave frequency characteristics.
2ND IF AND DEMODULATOR CIRCUITS
2nd IF filter
450 kHz
C180
R175
R176
"SQLO" signal to the D/A
convertor IC (IC190, pin 15)
"SQLI" signal to the D/A
convertor IC (IC190, pin 16)
5
FI170
3
IF amp.
11
12
C174
R171
R170
R5V
X170
450 kHz
4-1
16
IC170 TA31136FN(D)
"IF" (1st IF signal: 21.7 MHz)
from RF unit, Q151
"NOISV" signal to the CPU (pin 2)
"RSSIV" signal to the CPU (pin 1)
C171
R172
14
17
16
PLL IC
IC1
X1
21.25 MHz
Noise
comp.
RSSI
10
2
2nd
Mixer
FM
detector
9
C176
7
Noise
detector
Active
filter
C175
AF signal "DET"
C179
8 R174
4-1-5 SQUELCH CIRCUIT (MAIN UNIT)
4-2-3 DRIVE/POWER AMPLIFIER CIRCUITS
(MAIN UNIT)
The noise squelch circuit cuts out AF signals when no RF
signals are received. By detecting noise components in the
AF signals, the squelch circuit switches the AF mute switch.
The signal from the VCO circuit passes through the transmit/receive switching circuit (D50, D51) and is applied to the
buffer-amplifier (Q50). The amplified signal is amplified by
the pre-driver (Q53) and the power amplifier (Q54) to obtain
5 W of RF power (at 7.2 V). The amplified signal passes
through the antenna switching circuit (D52), and low-pass filter (L81, L82, C83–C86, C89) and is then applied to the
antenna connector.
A portion of the AF signals divided by C175 from the FM IF
IC (IC170, pin 9) are applied to the D/A convertor (IC190, pin
16) to adjust amplitude. The signals from the D/A convertor
(IC190, pin 15) are applied to the active filter section (IC170,
pin 8). The active filter section amplifies and filters noise
components. The filtered signals are applied to the noise
detector section and output from IC170 (pin 14) as the
“NOISV” signal.
The bias current of the pre-driver (Q53) and the power
amplifier (Q54) is controlled by the APC circuit to stabilize
the output power.
The “NOISV” signal from IC170 (pin 14) is applied to the
CPU (IC360, pin 2). The CPU compares the set squelch
level voltage and “NOISV” signal voltage to control the
squelch output.
4-2-4 APC CIRCUIT (MAIN UNIT)
The APC circuit provides stable output power from the
power amplifier even when the input voltage or temperature
changes, and, selects HIGH or LOW output power. The APC
circuit consists of a power detector and APC control circuits.
4-2 TRANSMITTER CIRCUITS
• POWER DETECTOR CIRCUIT (MAIN UNIT)
The power detector circuit (D80, C87) detects the transmit
output power level and converts it to DC voltage as the
“TDETV” signal. The detected signal is applied to the TX
control circuit.
4-2-1 MICROPHONE AMPLIFIER CIRCUIT
(MAIN UNIT)
The microphone amplifier circuit amplifies audio signals with
+6 dB/octave pre-emphasis characteristics from the microphone to a level needed for the modulation circuit.
• APC CONTROL CIRCUIT (MAIN UNIT)
The detected signal from the power detector circuit (D91,
R280) is applied to the CPU (IC360, pin 4) to control the
input voltage of the pre-driver (Q53) and the power amplifier (Q54). When the output power changes, the CPU (IC360)
outputs APC control signal to the D/A converter (IC190). And
then “PCON” signal from the D/A converter controls the APC
controller (IC50) to provide stable output power.
The AF signals from the microphone are passed through the
pre-emphasis circuit (R253, C254) and are then applied to
the microphone amplifier (IC200b). The amplified AF signals
are applied to analog switch (IC260, pin 5).
The AF signals are amplified again at the limiter-amplifier
(IC200a) and then passed through the low-pass filter
(IC200d, pins 12 and 13). The filtered audio is applied to the
RF unit as the “MOD” signal.
4-2-2 MODULATION CIRCUIT (MAIN UNIT)
The modulation circuit modulates the VCO oscillating signal
(RF signal) using the microphone audio signals.
The audio signals “MOD” change the reactance of D20 to
modulate an oscillated signal at the VCO circuit (Q21, Q22,
D22, D23). The oscillated signal is amplified at the bufferamplifiers (Q23, Q24).
APC CIRCUIT
PWR det.
"TDETV" signal to the CPU
IC360 (pin 4)
D80, C87
Pre-Drive
The amplified signal from the
buffer amplifier (Q50)
"PCON" signal
from IC190 (pin 3)
Q53
TX
PWR amp.
Q54
D52
APC ctrl
+
D91
IC50
RX
"TXMS" signal to the CPU
IC360 (pin 11)
"T5V"
TX MUTE SW
Q351
D90
To the 1st IF circuit
Ant SW
4-2
Ant
4-3 PLL CIRCUIT (MAIN UNIT)
4-4 POWER SUPPLY CIRCUITS
A PLL circuit provides stable oscillation of the transmit frequency and receive 1st LO frequency. The PLL output compares the phase of the divided VCO frequency to the reference frequency. The PLL output frequency is controlled by
the divided ratio (N-data) of a programmable divider.
VOLTAGE LINES
LINE
VCC
DESCRIPTION
The voltage from the attached battery pack.
The PLL circuit contains a VCO (Q21, Q22, D22, D23). The
oscillated signal is amplified at the buffer-amplifiers (Q23,
Q25) and then applied to the PLL IC (IC1, pin 19).
CPU5V
Common 5 V converted from the VCC line by the
CPU5V regulator circuit (IC220).
The output voltage is applied to the CPU
(IC360), REG5V regulator, etc.
The PLL IC contains the prescalers, programmable counter,
programmable divider, phase selector and etc. The entered
signal is divided at the prescaler and programmable counter
sections by the N-data ratio from the CPU. The divided signal is detected on phase at the phase detector using the reference frequency.
5V
Common 5V converted from the VCC line by the
5V regulator circuit (Q223–Q225).
The output voltage is applied to the D/A converter (IC190) and PLL IC (IC1), etc.
R5V
Receive 5V converted from the 5V line by the R5
regulator circuit (Q221).
The regulated voltage is applied to the MOD
MUTE circuit (Q20, D20, D21) and receiver circuit.
V5V
Common 5V converted from the 5V line by the
V5 regulator circuit (Q220).
The regulated voltage is applied to the VCO circuit
T5V
Transmit 5V converted from the 5V line by the T5
regulator circuit (Q222).
The regulated voltage is applied to the transmitter circuit.
If the oscillated signal drifts, the phase of its frequency
changes from the reference frequency, causing a lock voltage changes to compensate for the drift in the oscillated frequency.
A portion of the VCO signal is amplified at buffer-amplifiers
(Q23, Q24) and is then applied to the receive 1st mixer
(Q150) or transmit driver via the TX/RX switching diode
(D50, D51).
PLL CIRCUIT
D50
Buffer
Buffer
VCO
Q23
Q21, Q22, D22, D23
X1
21.25 MHz
Q24
to the 1st mixer circuit
D51
Buffer
Q25
Loop
filter
"2nd LO" signal (21.25 MHz)
to the FM IF IC (IC170)
to transmitter circuit
IC1 (PLL IC)
Programmable
counter
13
Phase
detector
17
Programmable
divider
16
4-3
Prescaler
Shift register
19
3
4
5
PLST
SCK
SDATA
4-5 PORT ALLOCATIONS
4-5-1 CPU (IC360)
Pin
number
Port
name
Description
1
RSSIV
Input port for the RSSI signal to control S-meter from the FM IF IC (IC170
pin 12).
NOISV
Input port for the NOIS signal to control squelch circuit from the FM IF IC
(IC170 pin 14).
2
3
BATTV
Input port for the battery voltage
detection.
4
TDETV
Input port for the TX power detection.
5
TEMPV
Input port for transceiver’s internal
temperature detection.
6
SCK
Outputs serial clock.
7
SDATA
Outputs serial data.
10
LEDS
Outputs key pad and LCD back light
control signal.
High : While lights ON.
12
BEEP
Outputs beep audio signals.
13
PLST
Outputs strobe signals to the PLL IC
(IC1, pin 3).
14
15
DAST
5VS
Outputs strobe signals to the D/A convertor IC (IC190, pin 6).
Outputs the M5V regulator control signal.
Pin
number
Port
name
Description
43
CH/WX
Input port for the [CH/WX] key.
Low : While [CH/WX] key is pushed.
44
UP
Input port for the [Y] key.
Low : While the [Y] key is pushed.
45
DOWN
Input port for the [Z] key.
Low : While the [Z] key is pushed.
46
16
Input port for the [16] key.
Low : While the [16] key is pushed.
47
AFMS
Output the speaker mute switch control signal.
High : While the AF output is muted.
Outputs RF bandpass filters control
signal.
High : While
receiving
below
159.990 MHz.
Low : While
receiving
above
160.000 MHz.
48
BPFS
49
V5VS
Outputs the 5V regulator control signal.
50
T5VS
Outputs the T5V regulator control signal.
51
R5VS
Outputs the R5V regulator control signal.
52
AFVS
Outputs the AF regulator control signal.
16
LCDS
Outputs LCD contrast signal.
18
ESCK
Outputs serial clock signal for the
EEPROM (IC340, pin 6).
53
MICM
Outputs the MIC mute switch control
signal.
19
CLOUT
Outputs the cloning data.
54
DETM
20
CLIN
Outputs the detector mute control signal.
Low : While muting.
22
PWSW
Input port for the power switch control
signal.
55
VOL UP
Input port for the volume control signal.
23
UNLK
Input port for the PLL unlock signal.
High : PLL is unlocked.
24
ESDA
I/O port for the serial data signals to
the EEPROM (IC340, pin 5).
27
TDEC
30
31
Input port for the cloning data.
4-5-2 D/A converter IC (IC190)
Pin
number
Port
name
Description
Outputs the decode monitor signal.
High : While muting.
2
FCON
Outputs the reference frequency
adjusting signal.
PTT
Input port for the [PTT] switch.
High : While the [PTT] switch is
pushed.
3
WET
Input port for transceiver’s internal
inundation detection.
10
MCON
Outputs the transmit modulation
adjusting signal.
39
SCAN
Input port for the [SCN] key.
Low : While the [SCN] key is
pushed.
11
BEPO
Outputs the beep tone level adjusting
signal while “AUTO” is selected in set
mode.
40
H/L
Input port for the [H/L] key.
Low : While the [H/L] key is pushed.
14
BEPST
Outputs the beep tone level adjusting
signal while 1–10 level is selected in
set mode.
41
VOL
DOW
Input port for the volume control signal.
15
SQLO
Outputs the squelch level adjusting
signal.
42
SQL
Input port for the [SQL] key.
Low : While the [SQL] key is
pushed.
4-4
PCON
Outputs the TX power adjusting signal.
SECTION 5 ADJUSTMENT PROCEDURES
5-1 PREPARATION
When adjusting IC-M32, the optional CS-M32 CLONING SOFTWARE (Rev. 1.0 or later), OPC-478 CLONING CABLE are required.
GRADE AND RANGE
EQUIPMENT
DC power supply
Output voltage
Current capacity
: 7.5 V DC
: 3 A or more
RF power meter
(terminated type)
Measuring range
Frequency range
Impedance
SWR
:
:
:
:
Frequency counter
Digital multimeter
0.1–10 W
100–300 MHz
50 Ω
Less than 1.2 : 1
Frequency range
: 0.1–300 MHz
Frequency accuracy : ±1 ppm or better
Sensitivity
: 100 mV or better
Input impedance
EQUIPMENT
GRADE AND RANGE
FM deviation meter
Frequency range
Measuring range
: 30–300 MHz
: 0 to ±10 kHz
Audio generator
Frequency range
Measuring range
: 300–3000 Hz
: 1–500 mV
Frequency range
Output level
: 100–300 MHz
: 0.1 µV–32 mV
(–127 to –17 dBm)
Power attenuation
Capacity
: 40 dB or more
: 10 W or more
Standard signal
generator (SSG)
Attenuator
: 10 MΩ/DC or better
■ BEFORE ENTERING THE ADJUSTMENT MODE
• Cloning the adjustment frequency 156.800 MHz on the programmable CH.
(No select POC function POC ON on the adjustment frequency. )
■ ENTERING THE ADJUSTMENT MODE
• Push and hold the [H/L] key and [PTT] switch, and then turn power ON.
■ OPERATING IN THE ADJUSTMENT MODE
• Change adjustment items:
• Change adjustment values:
[16] key
[Y] and [Z] keys
■ EXITING THE ADJUSTMENT MODE
When adjustment is finished, need to do follow operation to cancel the adjustment mode. Otherwise, the transceiver does not
work properly.
• Turn power OFF.
• Push and hold the [H/L] key and [PTT] switch, and then turn power ON.
• DC POWER CABLE CONNECTION
DC power supply
+
connect (soldering)
line here
connect (soldering) + line here
Top view
5-1
• CONNECTION
to the antenna connector Standard signal generator
CAUTION!
0.1 V to 32 mV
( 127 dBm to 17 dBm)
DO NOT transmit while
an SSG is connected to
the antenna connector.
Audio generator
SINAD meter
Speaker (8
to [MIC] jack
Attenuator
40 dB or 50 dB
to [SP] jack
RF power meter
0.1 10 W/50
FM deviation meter
Frequency
counter
)
OPC-782
Optional plug adapter
cable
AD-98FSC
Optional STUD-BNC
adapter
DETACHING/ATTACHING THE TOP PANEL
CAUTION!
DO NOT detach the TOP PANEL
except for adjustment or cloning
to maintain the water resistance
capability.
Detach the TOP PANEL with a
sharp point such as tweezers for
adjustment.
BE CAREFUL cracking the TOP
PANEL.
After adjustment, be sure to
reattach the TOP PANEL to
maintain the water resistance
capability.
NOTE: If the tape on the back of the TOP PANEL has lost its
adhesion, replacement to a new one is necessary.
5-2
5-2 PLL AND RX SENSITIVITY ADJUSTMENTS
ADJUSTMENT
LOCK
VOLTAGE
ADJUSTMENT CONDITION
1 • Operating frq.
• Receiving
: 156.800 MHz
2 • Operating frq.
• Output power
• Transmitting
: 156.800 MHz
: Low
1 • Operating frq. : 156.800 MHz
RX
• Set an SSG as:
SENSITIVITY
Frequency
: 156.800 MHz
Level
: 3.2 µV*
(–97 dBm)
Modulation
: 1 kHz
Deviation
: ±3.5 kHz
• Receiving
MEASUREMENT
UNIT
LOCATION
MAIN
Connect a digital
multi-meter or oscilloscope
to
the
check point CP1.
VALUE
ADJUSTMENT
POINT
UNIT
1.8 V
ADJUST
Verify
1.7 V
Top
Panel
Connect an SSG to
the antenna connector and a SINAD
meter with 8 Ω load
to the [SP] jack.
0.35 µV (–116 dBm)
*The output level of the standard signal generator (SSG) is indicated as the SSG’s open circuit.
CP1
PLL lock voltage
check point
5-3
Verify
5-3 ADJUSTMENT MODE ADJUSTMENTS
Select an operation using [16] key, then set specified value using [Y] / [Z] keys on the front panel of IC-M32.
ADJUSTMENT
ADJUSTMENT CONDITION
MEASUREMENT
UNIT
LOCATION
VALUE
REFERENCE
FREQUENCY
[Fr]
1 • Operating frq. :156.800 MHz
Top Loosely couple the frequency
• Output power : Low
Panel counter to the antenna connec• Connect an RF power meter or a 50 Ω
tor.
dummy load to the antenna connector.
• Transmitting
OUTPUT
POWER
[Po H] (Hi)
1 • Operating frq.
• Output power
• Transmitting
: 156.800 MHz
: Hi
[Po L] (Low)
2 • Output power
• Transmitting
: Low
0.8 W
[Po ML]
(Extra-Low)
3 • Output power
• Transmitting
: Extra-Low
0.45 W
FM
DEVIATION
[dE]
1 • Operating frq. : 156.800 MHz
Top Connect an FM deviation meter
• Output power : Low
panel to the antenna connector
• Connect an audio generator to the [MIC]
through an attenuator.
jack and set as:
1 kHz/25 mV
• Set an FM deviation meter as:
HPF
: OFF
LPF
: 20 kHz
De-emphasis : OFF
Detector
: (P–P)/2
• Transmitting
SQUELCH
LEVEL
[nL]
1 • Operating frq. : 156.800 MHz
• Set an SSG as:
Frequency
: 156.800 MHz
Level
: 0.63 µV*
(–111 dBm)
Modulation
: 1 kHz
Deviation
: ±3.5 kHz
• Receiving
Top Connect an RF power meter to
panel the antenna connector.
Top Connect an SSG to the antenna
panel connector and a SINAD meter
with 8 Ω load to the [SP] jack.
2 • Receiving
156.8000 MHz
5.0 W
±4.3 kHz
More than 12 dB
SINAD
• Push [Z] key to
set squelch level
to “01” at the sub
channel readout.
• Then, push [Y]
key to set squelch
level to “00” at the
sub channel readout.
*The output level of the standard signal generator (SSG) is indicated as the SSG’s open circuit.
TX power Hi/Low is selectable on all adjustment items.
5-4
SECTION 6
PARTS LIST
[MAIN UNIT]
[MAIN UNIT]
REF
NO.
ORDER
NO.
IC1
IC50
IC170
IC190
IC200
IC220
IC260
IC280
IC340
IC341
IC360
1130007610
1120002830
1110003200
1190000350
1110003780
1110005350
1140003830
1110001810
1130011540
1110006210
1140011630
S.IC
S.IC
S.IC
S.IC
S.IC
S.IC
S.IC
S.IC
S.IC
S.IC
S.IC
µPD3140GS-E1 (DS8)
NJM2125F-TE1
TA31136FN (EL)
M62363FP-650C
NJM2902V-TE1
NJM2870F05-TE1
TC4W66F (TE12L)
TA7368F (ER)
BR24L16FV-WE2
BD5242FVE-TR
M37560M8A-700GP (FX-2691A)
B
T
B
B
B
T
B
T
B
B
B
Q20
Q21
Q22
Q23
Q24
Q25
Q50
Q53
Q54
Q90
Q150
Q151
Q220
Q221
Q222
Q223
Q224
Q225
Q230
Q231
Q240
Q250
Q280
Q350
Q351
1590000430
1530002920
1530002920
1530002380
1530002380
1530002380
1530002920
1560001240
1560001230
1530002920
1580000760
1530002360
1510000670
1510000670
1510000670
1590000430
1590001190
1520000450
1520000450
1590001190
1590000430
1590002530
1530003090
1590000660
1590000720
S.TRANSISTOR
S.TRANSISTOR
S.TRANSISTOR
S.TRANSISTOR
S.TRANSISTOR
S.TRANSISTOR
S.TRANSISTOR
S.FET
S.FET
S.TRANSISTOR
S.FET
S.TRANSISTOR
S.TRANSISTOR
S.TRANSISTOR
S.TRANSISTOR
S.TRANSISTOR
S.TRANSISTOR
S.TRANSISTOR
S.TRANSISTOR
S.TRANSISTOR
S.TRANSISTOR
S.TRANSISTOR
S.TRANSISTOR
S.TRANSISTOR
S.TRANSISTOR
DTC144EUA T106
2SC4226-T1 R25
2SC4226-T1 R25
2SC4215-Y (TE85R)
2SC4215-Y (TE85R)
2SC4215-Y (TE85R)
2SC4226-T1 R25
RD01MUS1
RD07MVS1
2SC4226-T1 R25
3SK299-T1 U73
2SC2714-Y (TE85R)
2SA1588-GR (TE85R)
2SA1588-GR (TE85R)
2SA1588-GR (TE85R)
DTC144EUA T106
XP6501-(TX) .AB
2SB1132 T100 Q
2SB1132 T100 Q
XP6501-(TX) .AB
DTC144EUA T106
UN911H (TX)
2SC4213-B (TE85R)
DTC144TU T106
DTA144EUA T106
B
B
B
B
B
B
T
T
T
B
B
T
T
T
T
B
B
B
T
T
B
B
T
B
T
D1
D20
D21
D22
D23
D50
D51
D52
D80
D90
D91
D92
D93
D130
D350
D353
1750000770
1790001260
1790000620
1720000780
1720000780
1790000620
1790000620
1750000580
1790001670
1750000580
1790001670
1790000620
1790000660
1790000620
1750000370
1790000660
S.VARICAP
S.DIODE
S.DIODE
S.VARICAP
S.VARICAP
S.DIODE
S.DIODE
S.DIODE
S.DIODE
S.DIODE
S.DIODE
S.DIODE
S.DIODE
S.DIODE
S.DIODE
S.DIODE
HVC376BTRF
MA2S077-(TX)
MA77 (TX)
HVU350B TRF
HVU350B TRF
MA77 (TX)
MA77 (TX)
1SV307 (TPH3)
RB706F-40T106
1SV307 (TPH3)
RB706F-40T106
MA77 (TX)
MA728 (TX)
MA77 (TX)
DA221 TL
MA728 (TX)
B
B
B
B
B
T
T
T
T
B
T
B
B
B
B
B
FI150
FI151
FI170
2030000350
2030000270
2020001270
MONOLITH
MONOLITH
CERAMIC
21R15AB (FL-368)
FL-363 (21.7 MHz)
CFWLB450KE2A-B0
B
B
B
X1
X170
X360
6050011740
6070000190
6060010290
S.XTAL
CR-766 (21.250 MHz)
S.DISCRIMINATOR CDBCB450KCAY24-R0
S.XTAL
CR-610 (7.9872 MHz)
B
B
B
L1
L20
L21
L22
L23
L24
L25
L50
L51
L53
L55
L56
L57
6200008070
6200007000
6200003090
6200008190
6200006980
6200006980
6200006980
6200006980
6200007000
6200007690
6200009240
6200010640
6200008230
S.COIL
S.COIL
S.COIL
S.COIL
S.COIL
S.COIL
S.COIL
S.COIL
S.COIL
S.COIL
S.COIL
S.COIL
S.COIL
B
B
B
B
B
B
B
T
T
T
T
T
T
DESCRIPTION
MLF1608E 6R8K 6.8U
ELJRE 82NG-F
NL 322522T-2R7J-3
0.25-1.9-8TL 80N
ELJRE R10G-F
ELJRE R10G-F
ELJRE R10G-F
ELJRE R10G-F
ELJRE 82NG-F
LQW2BHN18NJ01L
0.20-1.0-7TL 31N
0.26-1.0-3TL 8.5N
0.30-1.3-5TL 22N
REF
NO.
M.
M.=Mounted side (T: Mounted on the Top side, B: Mounted on the Bottom side)
6-1
ORDER
NO.
DESCRIPTION
M.
L58
L80
L81
L82
L90
L91
L92
L93
L94
L95
L120
L121
L122
L130
L131
L132
L133
L150
6200003710
6200008280
6200009800
6200008580
6200008280
6200007760
6200007760
6200008190
6200008190
6200006980
6200002430
6200002410
6200003550
6200007760
6200007760
6200008190
6200008190
6200003680
S.COIL
S.COIL
S.COIL
S.COIL
S.COIL
S.COIL
S.COIL
S.COIL
S.COIL
S.COIL
S.COIL
S.COIL
S.COIL
S.COIL
S.COIL
S.COIL
S.COIL
S.COIL
NL 252018T-2R7J
0.30-1.7-7TL 50N
0.26-1.1-7TR 30N
0.30-1.4-6TL 32N
0.30-1.7-7TL 50N
LQW2BHN82NJ01L
LQW2BHN82NJ01L
0.25-1.9-8TL 80N
0.25-1.9-8TL 80N
ELJRE R10G-F
NL 252018T-082J
NL 252018T-056J
MLF1608A 4R7K-T
LQW2BHN82NJ01L
LQW2BHN82NJ01L
0.25-1.9-8TL 80N
0.25-1.9-8TL 80N
LQH31MNR82M01L
T
T
B
T
B
B
B
B
B
B
T
T
B
B
B
B
B
B
R1
R2
R3
R4
R5
R6
R7
R8
R9
R10
R20
R22
R23
R24
R25
R26
R27
R28
R29
R30
R31
R32
R33
R34
R35
R36
R50
R52
R53
R54
R55
R56
R57
R65
R66
R67
R68
R69
R70
R71
R72
R73
R74
R75
R76
R80
R81
R82
R90
R91
R93
R94
R95
R96
R100
R120
R121
R130
R131
R132
R133
7510001660
7030003940
7030003560
7030003640
7030003380
7030003440
7030003640
7030003440
7030003200
7030003480
7030003320
7030003410
7030003440
7030003680
7030003680
7030003550
7030003550
7030003350
7030003390
7030003660
7030003420
7030003390
7030003630
7030003400
7030003660
7030003440
7030003440
7030003520
7030003320
7030003260
7030003500
7030003450
7030003310
7030003700
7030003640
7030003680
7030003320
7030003580
7030003580
7030003320
7030003280
7030003440
7030003560
7030003320
7030000280
7030003670
7030003600
7030003560
7030003560
7030003440
7030003440
7030003620
7030003320
7030003360
7030003860
7030003480
7030003560
7030003560
7030003440
7030003560
7030003560
S.THRMISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
NTCG16 4LH 473KT
ERJ3GEYF 104 V (100 kΩ)
ERJ3GEYJ 103 V (10 kΩ)
ERJ3GEYJ 473 V (47 kΩ)
ERJ3GEYJ 331 V (330 Ω)
ERJ3GEYJ 102 V (1 kΩ)
ERJ3GEYJ 473 V (47 kΩ)
ERJ3GEYJ 102 V (1 kΩ)
ERJ3GEYJ 100 V (10 Ω)
ERJ3GEYJ 222 V (2.2 kΩ)
ERJ3GEYJ 101 V (100 Ω)
ERJ3GEYJ 561 V (560 Ω)
ERJ3GEYJ 102 V (1 kΩ)
ERJ3GEYJ 104 V (100 kΩ)
ERJ3GEYJ 104 V (100 kΩ)
ERJ3GEYJ 822 V (8.2 kΩ)
ERJ3GEYJ 822 V (8.2 kΩ)
ERJ3GEYJ 181 V (180 Ω)
ERJ3GEYJ 391 V (390 Ω)
ERJ3GEYJ 683 V (68 kΩ)
ERJ3GEYJ 681 V (680 Ω)
ERJ3GEYJ 391 V (390 Ω)
ERJ3GEYJ 393 V (39 kΩ)
ERJ3GEYJ 471 V (470 Ω)
ERJ3GEYJ 683 V (68 kΩ)
ERJ3GEYJ 102 V (1 kΩ)
ERJ3GEYJ 102 V (1 kΩ)
ERJ3GEYJ 472 V (4.7 kΩ)
ERJ3GEYJ 101 V (100 Ω)
ERJ3GEYJ 330 V (33 Ω)
ERJ3GEYJ 332 V (3.3 kΩ)
ERJ3GEYJ 122 V (1.2 kΩ)
ERJ3GEYJ 820 V (82 Ω)
ERJ3GEYJ 154 V (150 kΩ)
ERJ3GEYJ 473 V (47 kΩ)
ERJ3GEYJ 104 V (100 kΩ)
ERJ3GEYJ 101 V (100 Ω)
ERJ3GEYJ 153 V (15 kΩ)
ERJ3GEYJ 153 V (15 kΩ)
ERJ3GEYJ 101 V (100 Ω)
ERJ3GEYJ 470 V (47 Ω)
ERJ3GEYJ 102 V (1 kΩ)
ERJ3GEYJ 103 V (10 kΩ)
ERJ3GEYJ 101 V (100 Ω)
MCR10EZHJ 150 Ω (151)
ERJ3GEYJ 823 V (82 kΩ)
ERJ3GEYJ 223 V (22 kΩ)
ERJ3GEYJ 103 V (10 kΩ)
ERJ3GEYJ 103 V (10 kΩ)
ERJ3GEYJ 102 V (1 kΩ)
ERJ3GEYJ 102 V (1 kΩ)
ERJ3GEYJ 333 V (33 kΩ)
ERJ3GEYJ 101 V (100 Ω)
ERJ3GEYJ 221 V (220 Ω)
ERJ3GE JPW V
ERJ3GEYJ 222 V (2.2 kΩ)
ERJ3GEYJ 103 V (10 kΩ)
ERJ3GEYJ 103 V (10 kΩ)
ERJ3GEYJ 102 V (1 kΩ)
ERJ3GEYJ 103 V (10 kΩ)
ERJ3GEYJ 103 V (10 kΩ)
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
B
T
T
B
B
B
B
B
B
T
T
B
B
B
B
B
S.=Surface mount
[MAIN UNIT]
REF
NO.
R134
R150
R151
R152
R153
R154
R155
R156
R170
R171
R172
R173
R174
R175
R176
R192
R193
R194
R201
R202
R203
R204
R205
R206
R207
R212
R213
R214
R220
R221
R222
R223
R224
R225
R226
R227
R228
R230
R231
R232
R233
R234
R235
R236
R240
R241
R242
R245
R250
R251
R252
R253
R255
R256
R257
R258
R260
R261
R262
R263
R264
R265
R271
R272
R273
R274
R275
R276
R277
R278
R279
R281
R282
R283
R284
R286
R288
R289
R290
R300
R304
R305
R340
R341
R343
R345
R346
R350
[MAIN UNIT]
ORDER
NO.
7030003330
7030003320
7030003500
7030003460
7030003460
7030003680
7030003460
7030003400
7030003390
7030003450
7030003400
7030003460
7030003720
7030003640
7030003540
7030003390
7030003400
7030003680
7030003580
7030003680
7030003810
7030003520
7030003550
7030003590
7030003610
7030003460
7030003660
7030003580
7030003560
7030003520
7030003560
7030003520
7030003560
7030003520
7030003480
7030003560
7030003600
7030003610
7030003800
7030003440
7030003480
7030003500
7030005930
7030008090
7030003320
7030003420
7030003420
7030003440
7030003680
7030003400
7030003620
7030003480
7030003700
7030003590
7030003520
7030003520
7030003570
7030003510
7030003470
7030003680
7030003680
7030003680
7030003620
7030003710
7030003590
7030003750
7030003560
7030003710
7030003680
7030003440
7030003430
7030003620
7030003560
7030003260
7030003200
7030003560
7030003720
7030003700
7030003620
7030003540
7030003640
7030003640
7030003560
7030003560
7030003680
7030003760
7030003200
7030003760
DESCRIPTION
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
ERJ3GEYJ 121 V (120 Ω)
ERJ3GEYJ 101 V (100 Ω)
ERJ3GEYJ 332 V (3.3 kΩ)
ERJ3GEYJ 152 V (1.5 kΩ)
ERJ3GEYJ 152 V (1.5 kΩ)
ERJ3GEYJ 104 V (100 kΩ)
ERJ3GEYJ 152 V (1.5 kΩ)
ERJ3GEYJ 471 V (470 Ω)
ERJ3GEYJ 391 V (390 Ω)
ERJ3GEYJ 122 V (1.2 kΩ)
ERJ3GEYJ 471 V (470 Ω)
ERJ3GEYJ 152 V (1.5 kΩ)
ERJ3GEYJ 224 V (220 kΩ)
ERJ3GEYJ 473 V (47 kΩ)
ERJ3GEYJ 682 V (6.8 kΩ)
ERJ3GEYJ 391 V (390 Ω)
ERJ3GEYJ 471 V (470 Ω)
ERJ3GEYJ 104 V (100 kΩ)
ERJ3GEYJ 153 V (15 kΩ)
ERJ3GEYJ 104 V (100 kΩ)
ERJ3GEYJ 125 V (1.2 MΩ)
ERJ3GEYJ 472 V (4.7 kΩ)
ERJ3GEYJ 822 V (8.2 kΩ)
ERJ3GEYJ 183 V (18 kΩ)
ERJ3GEYJ 273 V (27 kΩ)
ERJ3GEYJ 152 V (1.5 kΩ)
ERJ3GEYJ 683 V (68 kΩ)
ERJ3GEYJ 153 V (15 kΩ)
ERJ3GEYJ 103 V (10 kΩ)
ERJ3GEYJ 472 V (4.7 kΩ)
ERJ3GEYJ 103 V (10 kΩ)
ERJ3GEYJ 472 V (4.7 kΩ)
ERJ3GEYJ 103 V (10 kΩ)
ERJ3GEYJ 472 V (4.7 kΩ)
ERJ3GEYJ 222 V (2.2 kΩ)
ERJ3GEYJ 103 V (10 kΩ)
ERJ3GEYJ 223 V (22 kΩ)
ERJ3GEYJ 273 V (27 kΩ)
ERJ3GEYJ 105 V (1 MΩ)
ERJ3GEYJ 102 V (1 kΩ)
ERJ3GEYJ 222 V (2.2 kΩ)
ERJ3GEYJ 332 V (3.3 kΩ)
ERJ3GEYF 334 V (330 kΩ)
ERJ3EKF 1503 V (150 kΩ)
ERJ3GEYJ 101 V (100 Ω)
ERJ3GEYJ 681 V (680 Ω)
ERJ3GEYJ 681 V (680 Ω)
ERJ3GEYJ 102 V (1 kΩ)
ERJ3GEYJ 104 V (100 kΩ)
ERJ3GEYJ 471 V (470 Ω)
ERJ3GEYJ 333 V (33 kΩ)
ERJ3GEYJ 222 V (2.2 kΩ)
ERJ3GEYJ 154 V (150 kΩ)
ERJ3GEYJ 183 V (18 kΩ)
ERJ3GEYJ 472 V (4.7 kΩ)
ERJ3GEYJ 472 V (4.7 kΩ)
ERJ3GEYJ 123 V (12 kΩ)
ERJ3GEYJ 392 V (3.9 kΩ)
ERJ3GEYJ 182 V (1.8 kΩ)
ERJ3GEYJ 104 V (100 kΩ)
ERJ3GEYJ 104 V (100 kΩ)
ERJ3GEYJ 104 V (100 kΩ)
ERJ3GEYJ 333 V (33 kΩ)
ERJ3GEYJ 184 V (180 kΩ)
ERJ3GEYJ 183 V (18 kΩ)
ERJ3GEYJ 394 V (390 kΩ)
ERJ3GEYJ 103 V (10 kΩ)
ERJ3GEYJ 184 V (180 kΩ)
ERJ3GEYJ 104 V (100 kΩ)
ERJ3GEYJ 102 V (1 kΩ)
ERJ3GEYJ 821 V (820 Ω)
ERJ3GEYJ 333 V (33 kΩ)
ERJ3GEYJ 103 V (10 kΩ)
ERJ3GEYJ 330 V (33 Ω)
ERJ3GEYJ 100 V (10 Ω)
ERJ3GEYJ 103 V (10 kΩ)
ERJ3GEYJ 224 V (220 kΩ)
ERJ3GEYJ 154 V (150 kΩ)
ERJ3GEYJ 333 V (33 kΩ)
ERJ3GEYJ 682 V (6.8 kΩ)
ERJ3GEYJ 473 V (47 kΩ)
ERJ3GEYJ 473 V (47 kΩ)
ERJ3GEYJ 103 V (10 kΩ)
ERJ3GEYJ 103 V (10 kΩ)
ERJ3GEYJ 104 V (100 kΩ)
ERJ3GEYJ 474 V (470 kΩ)
ERJ3GEYJ 100 V (10 Ω)
ERJ3GEYJ 474 V (470 kΩ)
REF
NO.
M.
B
B
B
B
T
T
T
T
T
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
T
T
T
T
T
T
B
B
B
T
T
T
T
T
T
T
B
B
B
T
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
T
T
T
B
T
T
T
B
B
B
B
B
B
B
B
T
B
M.=Mounted side (T: Mounted on the Top side, B: Mounted on the Bottom side)
6-2
ORDER
NO.
DESCRIPTION
102
153
102
102
102
102
102
102
473
473
103
103
103
682
682
104
823
823
823
153
103
272
123
222
102
103
V
V
V
V
V
V
V
V
V
V
V
V
V
V
V
V
V
V
V
V
V
V
V
V
V
V
M.
R351
R352
R353
R360
R361
R362
R363
R364
R366
R367
R371
R372
R373
R374
R375
R376
R377
R378
R379
R380
R381
R382
R383
R384
R385
R386
7030003440
7030003580
7030003440
7030003440
7030003440
7030003440
7030003440
7030003440
7030003640
7030003640
7030003560
7030003560
7030003560
7030003540
7030003540
7030003680
7030003670
7030003670
7030003670
7030003580
7030003560
7030003490
7030003570
7030003480
7030003440
7030003560
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
S.RESISTOR
ERJ3GEYJ
ERJ3GEYJ
ERJ3GEYJ
ERJ3GEYJ
ERJ3GEYJ
ERJ3GEYJ
ERJ3GEYJ
ERJ3GEYJ
ERJ3GEYJ
ERJ3GEYJ
ERJ3GEYJ
ERJ3GEYJ
ERJ3GEYJ
ERJ3GEYJ
ERJ3GEYJ
ERJ3GEYJ
ERJ3GEYJ
ERJ3GEYJ
ERJ3GEYJ
ERJ3GEYJ
ERJ3GEYJ
ERJ3GEYJ
ERJ3GEYJ
ERJ3GEYJ
ERJ3GEYJ
ERJ3GEYJ
(1 kΩ)
(15 kΩ)
(1 kΩ)
(1 kΩ)
(1 kΩ)
(1 kΩ)
(1 kΩ)
(1 kΩ)
(47 kΩ)
(47 kΩ)
(10 kΩ)
(10 kΩ)
(10 kΩ)
(6.8 kΩ)
(6.8 kΩ)
(100 kΩ)
(82 kΩ)
(82 kΩ)
(82 kΩ)
(15 kΩ)
(10 kΩ)
(2.7 kΩ)
(12 kΩ)
(2.2 kΩ)
(1 kΩ)
(10 kΩ)
C1
C2
C3
C4
C5
C6
C7
C8
C9
C10
C11
C12
C20
C21
C22
C24
C25
C26
C27
C28
C29
C30
C31
C32
C33
C34
C35
C36
C37
C38
C39
C40
C41
C42
C43
C44
C50
C51
C52
C53
C54
C55
C56
C57
C58
C59
C60
C61
C62
C63
C64
C65
C66
C67
C68
C70
C71
C72
C73
C74
4030016930
4030016790
4030007170
4030007040
4030007030
4030017460
4030016790
4030009520
4030009520
4030008920
4550006560
4030017460
4030017460
4030007000
4030007000
4030016930
4030017460
4030007090
4030007080
4030017460
4030017460
4030017460
4030017460
4030009540
4030007170
4030009540
4030017460
4030017460
4030009570
4030017460
4030007020
4030007030
4030017460
4030009920
4030007050
4030017460
4030017460
4030007050
4030017460
4030017460
4030007030
4030009650
4030016790
4030016930
4030016930
4030017730
4030017460
4510006970
4030017460
4030017730
4030017460
4030007130
4030017460
4030017730
4030007090
4030018020
4030008560
4030006860
4030006860
4030006860
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.TANTALUM
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.ELECTROLYTIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
ECJ0EB1A104K
ECJ0EB1C103K
C1608 CH 1H 221J-T
C1608 CH 1H 180J-T
C1608 CH 1H 150J-T
ECJ0EB1E102K
ECJ0EB1C103K
C1608 CH 1H 020B-T
C1608 CH 1H 020B-T
C1608 JB 1H 473K-T
ECST1CY225R
ECJ0EB1E102K
ECJ0EB1E102K
C1608 CH 1H 090D-T
C1608 CH 1H 090D-T
ECJ0EB1A104K
ECJ0EB1E102K
C1608 CH 1H 470J-T
C1608 CH 1H 390J-T
ECJ0EB1E102K
ECJ0EB1E102K
ECJ0EB1E102K
ECJ0EB1E102K
C1608 CH 1H 1R5B-T
C1608 CH 1H 221J-T
C1608 CH 1H 1R5B-T
ECJ0EB1E102K
ECJ0EB1E102K
C1608 CH 1H 0R3B-T
ECJ0EB1E102K
C1608 CH 1H 120J-T
C1608 CH 1H 150J-T
ECJ0EB1E102K
C1608 CH 1H 050B-T
C1608 CH 1H 220J-T
ECJ0EB1E102K
ECJ0EB1E102K
C1608 CH 1H 220J-T
ECJ0EB1E102K
ECJ0EB1E102K
C1608 CH 1H 150J-T
C1608 CH 1H 240J-T
ECJ0EB1C103K
ECJ0EB1A104K
ECJ0EB1A104K
ECJ0EB1E471K
ECJ0EB1E102K
ECEV1CA330WR
ECJ0EB1E102K
ECJ0EB1E471K
ECJ0EB1E102K
C1608 CH 1H 101J-T
ECJ0EB1E102K
ECJ0EB1E471K
C1608 CH 1H 470J-T
C1608 CH 1H 910J-T
C1608 CH 1H 300J-T
C1608 JB 1H 102K-T
C1608 JB 1H 102K-T
C1608 JB 1H 102K-T
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
T
T
T
T
T
T
T
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
T
T
T
T
T
T
T
T
T
T
T
T
B
T
T
T
T
T
T
T
T
T
T
T
T
S.=Surface mount
[MAIN UNIT]
REF
NO.
C75
C80
C81
C82
C83
C84
C85
C86
C87
C88
C89
C90
C91
C92
C93
C94
C95
C96
C97
C98
C99
C100
C101
C102
C103
C104
C105
C106
C107
C108
C109
C110
C120
C121
C122
C123
C130
C131
C132
C133
C134
C135
C136
C137
C138
C139
C140
C141
C142
C143
C150
C151
C152
C153
C154
C155
C156
C157
C158
C159
C160
C170
C171
C174
C175
C176
C177
C178
C179
C180
C181
C191
C192
C193
C194
C200
C202
C205
C206
C207
C220
C221
C222
C223
C224
C225
C226
C227
[MAIN UNIT]
ORDER
NO.
4030007050
4030006860
4030007040
4030007040
4030007050
4030011530
4030009650
4030007000
4030009500
4030017460
4030006980
4030007000
4030007010
4030007090
4030009910
4030007020
4030007070
4030007020
4030009510
4030017460
4030009910
4030007020
4030007070
4030007020
4030009920
4030007090
4030017460
4030017730
4030016790
4030007090
4030017730
4030017460
4030016790
4030006860
4030007030
4030007010
4030009920
4030007020
4030007070
4030017990
4030009510
4030017460
4030017460
4030009530
4030017990
4030007070
4030007020
4030009920
4030007020
4030017460
4030017460
4030007100
4030016970
4030017460
4030006860
4030011770
4030006860
4030016970
4030017460
4030016790
4030018240
4030017460
4030007120
4030017460
4030017460
4030017460
4030016930
4030011810
4030007140
4030007140
4030016930
4030016790
4510004630
4030016790
4030016790
4030016790
4030016930
4030016960
4030017460
4030016930
4510005430
4030016790
4030016790
4030016790
4510005430
4030011810
4030016790
4550006710
DESCRIPTION
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.ELECTROLYTIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.ELECTROLYTIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.ELECTROLYTIC
S.CERAMIC
S.CERAMIC
S.TANTALUM
C1608 CH 1H 220J-T
C1608 JB 1H 102K-T
C1608 CH 1H 180J-T
C1608 CH 1H 180J-T
C1608 CH 1H 220J-T
C1608 CH 1H 110J-T
C1608 CH 1H 240J-T
C1608 CH 1H 090D-T
C1608 CH 1H 0R5B-T
ECJ0EB1E102K
C1608 CH 1H 070D-T
C1608 CH 1H 090D-T
C1608 CH 1H 100D-T
C1608 CH 1H 470J-T
C1608 CH 1H 040B-T
C1608 CH 1H 120J-T
C1608 CH 1H 330J-T
C1608 CH 1H 120J-T
C1608 CH 1H 010B-T
ECJ0EB1E102K
C1608 CH 1H 040B-T
C1608 CH 1H 120J-T
C1608 CH 1H 330J-T
C1608 CH 1H 120J-T
C1608 CH 1H 050B-T
C1608 CH 1H 470J-T
ECJ0EB1E102K
ECJ0EB1E471K
ECJ0EB1C103K
C1608 CH 1H 470J-T
ECJ0EB1E471K
ECJ0EB1E102K
ECJ0EB1C103K
C1608 JB 1H 102K-T
C1608 CH 1H 150J-T
C1608 CH 1H 100D-T
C1608 CH 1H 050B-T
C1608 CH 1H 120J-T
C1608 CH 1H 330J-T
MCH185A130JK
C1608 CH 1H 010B-T
ECJ0EB1E102K
ECJ0EB1E102K
C1608 CH 1H 1R5B-T
MCH185A130JK
C1608 CH 1H 330J-T
C1608 CH 1H 120J-T
C1608 CH 1H 050B-T
C1608 CH 1H 120J-T
ECJ0EB1E102K
ECJ0EB1E102K
C1608 CH 1H 560J-T
ECJ0EB1C223K
ECJ0EB1E102K
C1608 JB 1H 102K-T
C1608 CH 1H 060B-T
C1608 JB 1H 102K-T
ECJ0EB1C223K
ECJ0EB1E102K
ECJ0EB1C103K
ECJ0EB1E562K
ECJ0EB1E102K
C1608 CH 1H 820J-T
ECJ0EB1E102K
ECJ0EB1E102K
ECJ0EB1E102K
ECJ0EB1A104K
C1608 JB 1A 224K-T
C1608 CH 1H 121J-T
C1608 CH 1H 121J-T
ECJ0EB1A104K
ECJ0EB1C103K
ECEV1CA100SR
ECJ0EB1C103K
ECJ0EB1C103K
ECJ0EB1C103K
ECJ0EB1A104K
ECJ0EB1C183K
ECJ0EB1E102K
ECJ0EB1A104K
ECEV0JA220SR
ECJ0EB1C103K
ECJ0EB1C103K
ECJ0EB1C103K
ECEV0JA220SR
C1608 JB 1A 224K-T
ECJ0EB1C103K
ECST1AX226R
REF
NO.
M.
T
T
T
T
T
T
T
T
T
T
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
T
T
T
T
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
T
T
T
T
T
T
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
T
T
T
B
B
T
B
M.=Mounted side (T: Mounted on the Top side, B: Mounted on the Bottom side)
6-3
ORDER
NO.
DESCRIPTION
M.
C228
C229
C230
C231
C232
C233
C240
C250
C251
C252
C254
C257
C260
C261
C262
C263
C264
C265
C266
C267
C268
C280
C281
C282
C283
C284
C285
C286
C287
C288
C289
C300
C340
C341
C350
C351
C352
C360
C361
C363
C364
C365
C366
C367
C368
C370
C371
C372
C373
C374
C375
C376
C377
C378
C379
C380
C381
C382
4030017460
4030017460
4550006820
4030008680
4030016930
4030016790
4030017460
4030016790
4510004630
4030017460
4030016790
4030016790
4510004630
4030016930
4030016790
4030016790
4030017780
4030007150
4030017030
4030011810
4030016930
4030017480
4550006140
4510004630
4030016930
4030017460
4030016930
4550006200
4030007150
4030016950
4510005370
4030017770
4030016790
4030017030
4030016790
4030007090
4030007090
4030016790
4030016950
4030016950
4030016950
4030016950
4030016950
4030017040
4030016950
4030007040
4030007050
4030016930
4030016930
4030016930
4030016930
4030016930
4030009490
4030017780
4030007100
4030017460
4030017460
4030017460
S.CERAMIC
S.CERAMIC
S.TANTALUM
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.ELECTROLYTIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.ELECTROLYTIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.TANTALUM
S.ELECTROLYTIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.TANTALUM
S.CERAMIC
S.CERAMIC
S.ELECTROLYTIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
S.CERAMIC
ECJ0EB1E102K
ECJ0EB1E102K
ECST1DX106R
C2012 JF 1C 105Z-T
ECJ0EB1A104K
ECJ0EB1C103K
ECJ0EB1E102K
ECJ0EB1C103K
ECEV1CA100SR
ECJ0EB1E102K
ECJ0EB1C103K
ECJ0EB1C103K
ECEV1CA100SR
ECJ0EB1A104K
ECJ0EB1C103K
ECJ0EB1C103K
ECJ0EB1E472K
C1608 CH 1H 151J-T
ECJ0EB1A273K
C1608 JB 1A 224K-T
ECJ0EB1A104K
C1608 JB 1A 474K-T
ECST1EY474R
ECEV1CA100SR
ECJ0EB1A104K
ECJ0EB1E102K
ECJ0EB1A104K
ECST0JY106R
C1608 CH 1H 151J-T
ECJ0EB1A473K
ECEV1AA221P
ECJ0EB1E332K
ECJ0EB1C103K
ECJ0EB1A273K
ECJ0EB1C103K
C1608 CH 1H 470J-T
C1608 CH 1H 470J-T
ECJ0EB1C103K
ECJ0EB1A473K
ECJ0EB1A473K
ECJ0EB1A473K
ECJ0EB1A473K
ECJ0EB1A473K
ECJ0EB1A333K
ECJ0EB1A473K
C1608 CH 1H 180J-T
C1608 CH 1H 220J-T
ECJ0EB1A104K
ECJ0EB1A104K
ECJ0EB1A104K
ECJ0EB1A104K
ECJ0EB1A104K
C1608 JB 1H 821K-T
ECJ0EB1E472K
C1608 CH 1H 560J-T
ECJ0EB1E102K
ECJ0EB1E102K
ECJ0EB1E102K
T
B
T
T
T
T
T
B
B
B
B
B
B
B
B
B
B
B
B
B
B
T
T
B
T
T
T
T
T
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
T
T
B
J250
J251
6450001910
6510021900
CONNECTOR
S.CONNECTOR
HSJ1594-010150
BM02B-ASRS-TF
B
T
DS240
DS241
DS242
DS243
DS244
DS245
DS246
5040002660
5040002660
5040002310
5040002310
5040002310
5040002310
5030002600
S.LED
S.LED
S.LED
S.LED
S.LED
S.LED
LCD
FY1101F-TR (LED)
FY1101F-TR (LED)
SML-311YTT86
SML-311YTT86
SML-311YTT86
SML-311YTT86
L3-0018TAY-1
T
T
T
T
T
T
T
MC250 7700002480
MICROPHONE
SKB-2746 LPC
T
S250
S328
2260001900
2260002710
SWITCH
S.SWITCH
SW-149 (SKHLLD)
SKQLLCE012
B
B
EP1
EP2
EP3
EP360
0910056712
6910014690
6910014690
8930057100
PCB
S.BEAD
S.BEAD
LCD CONTACT
B 6031B
MPZ1608S221A-T
MPZ1608S221A-T
SRCN-2497-SP-N-W
T
T
T
S.=Surface mount
[CHASSIS UNIT]
REF
NO.
ORDER
NO.
DESCRIPTION
J31
6910014190
CONNECTOR
2497 ANT CONNECTOR
SP1
2510001092
SPEAKER
036D0801B <FG>
W1
8900010960
CABLE
OPC-1129
M.
M.=Mounted side (T: Mounted on the Top side, B: Mounted on the Bottom side)
S.=Surface mount
6-4
SECTION 7
MECHANICAL PARTS AND DISASSEMBLY
[CHASSIS PARTS]
REF
NO.
J
31
ORDER
NO.
6910014190
[ACCESSORIES]
DESCRIPTION
2497 ANT connector
REF
NO.
QTY.
EP1
EP2
1
SP 1
2510001092
Speaker 036D0801B <FG>
1
W 1
8900010960
Cable OPC-1129
1
MP 1
MP 2
MP 4
MP 5
MP 6
MP 7
MP 8
MP 9
MP 14
MP 15
MP 16
MP 17
MP 21
MP 22
MP 23
MP 24
MP 25
MP 31
MP 32
MP 33
MP 34
MP 35
MP 36
MP 37
MP 38
MP 39
MP 40
MP 42
MP 43
MP 44
MP 46
MP 47
8210020090
8310059690
8930039000
8930060730
8930058020
8930056960
8610011151
8930056941
8850001950
8830001250
8210018500
8930057260
8210018482
8930056950
8810010120
8810010150
8850001880
8010019320
8930056980
8810009560
8930060770
8930056900
8810008640
8930056910
8810009510
8810009510
8510015970
8810009560
8510015980
8930024961
8930060780
8930060790
2691 front panel assembly
2691 front panel (incl. MP1)
1757 sheet
2691 keyboard
2497 PTT button
2497 PTT holder
Knob 2497 BATT lock-1
2497 lock plate-1 Y609A
Shieling washer (Y)
ANT connector-101 nut
2497 top panel
2497 top sheet
2497 rear panel-2
2497 main seal
Screw PH B0 M2x8 SUS ZK
Screw PH B0 2 x 10 SUS ZK
Shieling washer (W)
2691 chassis
2497 terminal holder
Screw PH BT M2x6 ZK
2691 A-terminal Y678
2497 B-terminal Y607
Screw FH BT No.0 M2x4 NI-ZU
2497 C-terminal Y608
Screw PH BT M2x4 NI-ZU
Screw PH BT M2x4 NI-ZU
2691 grounding plate
Screw PH BT M2x6 ZK
2691 main shield
891terminal rubber (A)-1
2691 PW button
2691 PW holder
1
1
1
1
1
1
1
1
1
1
1
1
1
1
3
1
1
1
1
2
1
1
2
1
1
7
1
2
1
3
1
1
ORDER
NO.
DESCRIPTION
250
251
6450001910
6510021900
Connector HSJ1594-010150
S. connector BM02B-ASRS-TF
1
1
S
S
250
328
2260001900
2260002710
switch SW-149 (SKHLLD)
S. switch SKQLLCE012
1
1
DS 246
5030002600
LCD L3-0018TAY-1
1
EP 360
8930057100
LCD contact SRCN-2497-SP-N-W
1
MC 250
7700002480
Microphone SKB-2746 LPC
1
MP
MP
MP
MP
MP
MP
8510014330
8510011101
8410002370
8210019970
8930060800
8930061580
2497 VCO case tip
1922 VCO cover-1 Y340A
2337 PA heatsink (tip) Y539
2691 reflector panel
2691 LCD holder
Sponge (HK)
1
1
1
1
1
1
20
21
50
360
361
362
Screw abbreviations
EP4
EP5
3310002321
Optional products
Optional products
Optional products
Optional products
Optional products
Antenna FA-SC55V-1
Charger BM-95V
Charger BC-147A
Charger BC-147E
Battery BP-224 ACC (750MAH)
Charger BC-150
MP1
MP2
MP3
MP4
8010018080
8930042041
8210028500
8930057260
Hand strap HK-009
1922 belt crip-1
2497 top panel
2497 top sheet
EP2
EP1
QTY.
J
J
QTY.
DESCRIPTION
[AUS]
[USA]
[SEA]
[AUS]
[AUS]
MP3
[MAIN UNIT]
REF
NO.
ORDER
NO.
B0, BT: Self-tapping, ZK: Black
NI-ZU: Nickel-zinc, SUS: Stainless
PH: Pan head, FH: Flat head
7-1
MP4
EP4
EP5
MP1
MP2
1
1
1
1
1
1
1
1
1
1
MP25 (C)
NOTE1
MP24 (C)
165 (6 1/2)
MP22 (C)
MP23 (C)
MP34 (C)
MP14 (C)
NOTE1
MP44 (C)
MP36 (C)
J31 (C)
NOTE1
MP360 (M)
MP21 (C)
MP32 (C)
136 (5 11/32)
135 (5 5/16)
136.1 (5 11/32)
DS246 (M)
MP23 (C)
MP35 (C)
MP361 (M)
MP33 (C)
58.4 (2 5/16)
0.3 (1/32)
56.2 (2 7/32)
2.8 (1/8)
0.3 (1/32)
MP38 (C)
MP44 (C)
EP360 (M)
36.1 (1 3/32)
4.7 (3/16)
41 (1 5/8)
8.5 (11/32)
2.3 (3/32)
MP37 (C)
MP23 (C)
MP39 (C)
SP1 (C)
NOTE2
<A figure of measurement>
UNIT : mm (inch)
MC250 (M)
W1 (C)
MP15 (C)
MP46 (C)
NOTE1
MP47 (C)
NOTE1
MP39 (C)
MP42 (C)
NOTE4
MP40 (C)
A
B
MP39 (C)
MP9 (C)
MP31 (C)
MP8 (C)
MP362 (M)
MP16 (C)
MP43 (C)
MP17 (C)
MP39 (C)
MP6 (C)
NOTE3
MP7 (C)
NOTE3
NOTE2
The glue must be applied to the
areas when the front panel is
replaced with new one, to ensure
water tightness.
Manufacture : Semedain Co.
Type
: Super-X
MP21 (M)
MP4 (C)
MP42 (C)
MP2 (C)
NOTE2
NOTE3
Once the 2497 PTT button (MP6 (C)) or
the 2497 PTT holder (MP7 (C)) is
removed, the glue must be applied
between the 2497 PTT button or the
2497 PTT holder and 2691 front panel.
Front side
MAIN unit
Rear side
MP39 (C)
MP6 (C)
MP7 (C)
Speaker
MP5 (C)
NOTE2
Window
Plate
NOTE1
Once the following parts are removed, a O ring or sealing must be replaced
with new one before reattachement.
MP1 (C)
Mother part . . . . . . . . . . . . . . . . . . Daughter part for relayted replacement
J31 (C) Antenna connector . . . . . . MP14 (C) Sealing washer
MP24 (C) Screw . . . . . . . . . . . . . . MP25 (C) Sealing washer
9-key
<Rear view of the front panel>
UNIT abbreviations (C): CHASSIS PARTS, (M): MAIN UNIT
7-2
NOTE4
MP42 (C)
A : For IC-M2A only
B : For IC-M32 only
NOTE: The MP31 (C) is a common
parts for IC-M2A and IC-M32. Need to
screw the MP42 (C) to the B location
for IC-M32.
¢ BC-150 CHARGER PARTS LIST
¡ELECTRICAL PARTS
[CHARGE UNIT]
REF. NO. ORDER NO.
DESCRIPTION
R1
R2
R3
7070001130 RESISTOR 120 ERG2SJ
7070001140 RESISTOR 150 ERG2SJ
7010007100 RESISTOR 1K PSD1/4V
J1
6510023070 CONNECTOR HEC2305-01-250
DS1
5040003020 LED SEL2410G
EP1
0910054642 PCB B-5787B
MP1(C)
¡MECHANICAL PARTS
[CHASSIS]
REF. NO. ORDER NO.
MP1
MP2
MP3
MP4
8510014350
8110007680
8810008660
8930047830
DESCRIPTION
QTY.
2523 Case
2523 Cover
Screw B0 3 x 8 NI-ZU (BT)
Leg cushion (C)
CHARGE unit
1
1
2
2
MP1 (CH)
MP2 (CH)
[CHARGE UNIT]
REF. NO. ORDER NO.
MP1
MP2
DESCRIPTION
QTY.
8930057120 2523 Terminal
8930057120 2523 Terminal
MP2 (C)
1
1
[ACCESSORIES]
MP4 (C)
REF. NO. ORDER NO.
MP1
DESCRIPTION
QTY.
8810001460 Screw A0 3.5 x 20 SUS
Screw abbreviations
¢ BC-150 VOLTAGE DIAGRAM
MP4 (C)
2
MP3 (C)
A0, B0, BT: Self-tapping
NI-ZU: Nickel-zinc
SUS: Stainless
NOTE: (C): CHASSIS
(CH): CHARGE UNIT
¢ BC-150 BOARD LAYOUT
¡TOP VIEW
16.4V (No load)
13.0V (Charge)
J1
HV
GND
GND
R1 120
16.4V (No load)
8.0V (Charge)
VCC
R3
MP1
DS1
R2
R2 150
MP1
+
J1
R3 1 k
DS1 TLG124A
¡BOTTOM VIEW
9.9V (No load)
16.4V (Charge)
GND
MP2
7-3
R1
MP2
–
B5787B
SECTION 8
SEMI-CONDUCTOR
INFORMATION
PARTS LIST
• TRANSISTOR AND FET’S
2SA1588 GR
(Symbol: ZG)
2SB1132 Q
(Symbol: BAQ)
2SC2714 Y
(Symbol: QY)
B
B
C
B
2SC4215 O
(Symbol: QO)
B
C
C
E
2SC4213 B
(Symbol: AB)
B
C
E
C
E
E
E
2SC4226 R25
(Symbol: R25)
B
G1
DTC144 TU
(Symbol: 06)
DTA144 EUA
(Symbol: 16)
3SK299 U73
(Symbol: U73)
C
C
E
G2
RD01MUS1
(Symbol: K2)
XP6501 AB
(Symbol: 5N)
E1
E
D
C1
B
B
B
S
UN911 H
(Symbol: 6P)
C
C
E
E
RD07MVS1
(Symbol: RD07MVS1)
D
G
E2
B1
S
B2
C2
D
D S
S
G
G
S
(Bottom view)
• DIODES
1SS375
(Symbol: FH)
DA221 TL
(Symbol: K)
1SV307
(Symbol: TX)
A
HVC376B TRF
(Symbol: B9)
A
C
A
A
C
C
MA2S077
(Symbol: S)
MA77
(Symbol: 4B)
MA728
(Symbol: 2A)
RB706F-40 T106
(Symbol: 3J)
A
C
HVU350 B
(Symbol: B0)
A
A
C
A
C
C
8-1
C
A
C
SECTION 9
BOARD LAYOUTS
The combination of this page and the next page shows
the unit layout in the same configuration as the actual
P.C. Board.
MAIN UNIT
• TOP VIEW
SP1
Mic
TAG
TAG
9
16
+ –
GND
CLONE
MONI
SQL
U/I/C
CH/WX
DUAL
SCN
SPO
DS246
VOL
–
VOL
+
LOCK
H/L
9-1
AFOUT
MIC
The combination of this page and the previous page
shows the unit layout in the same configuration as the
actual P.C. Board.
• BOTTOM VIEW
MIC
MC250
–
+
GND
CLONE
J250
SPO
MIC
AFOUT
ANT
9-2
SECTION 10
BLOCK DIAGRAM
CHASSIS
MAIN UNIT
ANTENNA
J1
REF OSC
21.250 MHz
VCC
Q21, Q22: 2SC4226
D22, D23: HVU350B
PLL IC
X1
CR-766
LOOP
FIL
IC1: µPD3140GS
D50, D51:
MA77
Q24:
2SC4215
BUFF
UNLK
FCON
HV
Q23:
2SC4215
TX/RX
SW
BUFF
Q53:
RD01MUS1
Q50:
2SC4226
PRE
DRIVE
BUFF
D52, D90:
1SV307
Q54:
RD07MVS1
PWR
AMP
ANT
SW
LPF
D80:
RB706F
T5V
Q20: DTC144EUA
D20: MA2S077
D21: MA77
BTYPE
MOD
MUTE
PLLO
VCO
BUFF
450 kHz
BPF
2ND LO
SP
APC
CTRL
BPF
Q351:
DAT144EUA
T5V
PWR DET
TX
MUTE SW
FI170:
CFWM450E
FI150: FL-368
FI151: FL-363
Q151:
2SC2714
IF DET IC
DET
D91:
RB706F
IC50: NJM2125F
Q25: 2SC4215
MODC
GND
PWR
DET
R5V
IF
AMP
IC170: TA31136FN
Q150:
3SK299
D130: MA77
RF
AMP
BPF
BPF
D92: MA77
D93: MA728
Q90:
2SC4226
BPF
LPF
21.7 MHz
BPFS
450kHz
POWER
POWER SW
RSSIV
NOISV
X170
CDBC450CX24
AF
AMP
DE-ENPHA
AF
MUTE
BEEP
VCC
VCC
Q223: DTC144EU
Q224: XP6501
Q225: 2SB1132
CLONE
MIC
AFMS
BTYPE
GND
REG
5V
IC200D:
NJM2902V
5VS
CPU
5V
TDETV
CPU5V
IC200C:
NJM2902V
(7.9872MHz)
Q350: DTC144TU
D350: DA221
LPF
LPF
IC200A:
NJM2902V
BUFF
LIMIT
CLOUT/CLIN
J250
IC220:
NJM2870F05
5V
R5V
REG
R5
AMP
X361
CSTCR7M98G53
IC341:
BD5242FVE
Q221:
2SA1588
R5VS
RESET
RESET
CPU
IC360:
M37560M8A-700GP
WXTV
IC200B:
NJM2902V
MIC
PRE
ENPHA
ATIS
Q220:
2SA1588
AMP
V5V
REG
V5
LED
SW
IC260: TC4W66F
ANALOG SW IC
DET
T5V
REG
T5
T5VS
MICM
KEY
DETM
Q250:
UN911H
DS240, DS241: FY1101F
DS242, DS243, DS244, DS245: SML-311YTT86
Q222:
2SA1588
PTT
PTT
PTT
CONT
LED
V5VS
Q240:
DTC144EUA
MOD
PTT SW
DS246:
L3-0018TAY-1
LCD
EXT
JACK
Q280: 2SC4213
IC280:
TA7368F
AF OUT
TXMS
D/A IC
IC190: M62363FP
VOLO
SPO
VCC
AF
REG
BEEPO
AFVS
VOLIN
PWSW
MODC
Q230: 2SB1132
Q231: XP6501
PCON
SQLI
FCON
SQLO
PCON
BEEP
PWSW
CLOUT/CLIN
PTT
10 -1
EEPROM
IC340:
BR24L16FV
NOTE:
COMMON LINE
Explanatory notes
TX LINE
RX LINE
RX LINE
TX LINE
COMMON LINE
SECTION 11
VOLTAGE DIAGRAM
MAIN UNIT
A
5V
5V
DET
MOD
RSSIV
VOLIN
BEPST
NOISV
BEPO
BEEP
VOLO
AFV
DET
MOD
RSSIV
1.90V
C202
0.1
R206
18 k
R204
4.7 k
R205
8.2 k
R378
82 k
C377
820 P
C378
0.0047
NOISV
BEPO
BEEP
R213
68 k
R212
1.5 k
R214
15 k
C205
0.018
R376
100 k
VOLO
AFV
C207
0.1
C206
0.001
R263
100 k
C282
10
R288
220 k
R289
150 k
1
2
3
4
5
6
7
5V
PTT
C376
0.1
R272
180 k
WDECV
C265
150 P
C262
0.01
R258
4.7 k
R257
4.7 k
C280
0.47
R290
33 k
R286
10 k
C367
0.033
C264
0.0047
C281
0.47
R282
10 k
C266
0.027
R278
1k
R265
100 k
C300
0.0033
C363
0.047
C365
0.047
C364
0.047
C285
0.1
RSSIV
NOISV
BATTV
TDETV
TEMPV
SCK
SDATA
WDECV
ATIS
LEDS
TXMS
BEEP
PLST
DAST
5VS
TEMPV
C366
0.047
R300
6.8 k
WET
C361
0.047
C350
0.01
CP350
CP351 CP352
R350
470 k
CP353
CLONE
CLONE
SPO
AFOUT
MIC
GND
CP354
CP355
R360 1 k
SCK
R361 1 k
BTYPE
D350
DA221
CP251
CP254
R352
15 k
SPO
GND
R364 1 k
16
S323
S328
S324
S321
CH/WX
UP
SQL
R305
47 k
CP360
C340
0.01
IC340
BR24L16FV-WE2
C352
47 P
1
2
3
4
S325
VOLUP
S327
S322
DOWN
C351
47 P
A0
A1
A2
VSS
8
VCC
7
WP
6
SCL
5
SDA
R340
10 k
X360
CSTCR7M98G53-RC
RESET
R341
10 k
R304
47 k
ESCK
ESDA
R343
100 k
C370
18 P
IC341
BD5242FVE-TR
C368
0.047
1
5
VOUT VDD
2
SUB
3
4
CT
GND
S326
VOLDOWN
C371
22 P
7.9872 MHz : 3.10 Vp-p
C341
0.027
DETM
AFMS
CLIN
MICM
CLOUT
C382
0.001
PWSW
75
SEG13
74
SEG14
73
SEG15
72
SEG16
71
SEG17
70
SEG18
69
SEG19
68
SEG20
67
SEG21
66
65
64
63
62
61
60
R366
59
47 k
58
57
56
VOLUP
55
DETM
54
MICM
53
52 AFVS
51 R5VS
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
C372
0.1
S329
H/L
SCAN
IC360
M37560M8A-700GP
SEG0
SEG1
SEG2
SEG3
SEG4
SEG5
SEG6
SEG7
SEG8
SEG9
SEG10
SEG11
SEG12
SEG13
SEG14
SEG15
SEG16
SEG17
SEG18
SEG19
SEG20
SEG21
COM0
COM1
COM2
WET
CPU5V
R351
1k
S320
SEG13
SEG14
SEG15
SEG16
SEG17
P30/SEG18
P31/SEG19
P32/SEG20
P33/SEG21
P34/SEG22
P35/SEG23
P36/SEG24
P37/SEG25
P00/SEG26
P01/SEG27
P02/SEG28
P03/SEG29
P04/SEG30
P05/SEG31
P06/SEG32
P07/SEG33
P10/SEG34
P11/SEG35
P12/SEG36
P13/SEG37
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
CP361
ESDA
CPU5V
Q350
DTC144TU
SP1
036D0801B
R362 1 k
DAST
P67/AN7
P66/AN6
P65/AN5
P64/AN4
P63/SCLK22/AN3
P62/SCLK21/AN2
P61/SOUT2/AN1
P60/SIN2/AN0
P57/ADET/DA2
P56/DA1
P55/CNTR1
P54/CNTR0
P53/RTP1
P52/RTP0
P51/PWM1
P50/PWM0
P47/SRDY1
P46/SCLK1
TXD
RXD
P43/TOUR
P42/INT2
P41/INT1
P40
P77
ESCK
R345
470 k
R353
1k
SPO
PLST
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
SEG0
SEG1
SEG2
SEG3
SEG4
SEG5
SEG6
SEG7
SEG8
SEG9
SEG10
SEG11
SEG12
SEG13
SEG14
SEG15
SEG16
SEG17
SEG18
SEG19
SEG20
SEG21
COM0
COM1
COM2
P76
P75
P74
P73
P72
P71
P70/INT0
RESET
XCIN
XCOUT
XIN
XOUT
VSS
P27
P26
P25
P24
P23
P22
P21
P20
P17
P16
P15/SEG39
P14/SEG38
CP252
J251
BM02B-ASRS-TF
1
2
PWSW
UNLK
SDATA R363 1 k
R346
10
CPU5V
4
3
ESCK
CLOUT
CLIN
CHEXT
PWSW
UNLK
ESDA
CP255
AFOUT
CLONE
SPO
AFOUT
MIC
GND
COM0
COM1
COM2
R367
470 k
Q280
2SC4213 B
MICM
J250
HSJ1594-010050
C360
0.01
C375
0.1
C267
0.22
R281
33 k
R273
18 k
5V
DETM
MICO
MICIN
ATIS
CP253
C374
0.1
CPU5V
C268
0.1
DETM
R264
100 k
C373
0.1
R275
10 k
PTTSW
S250
C287
150 P
C286
10
AFOUT
SCAN
H/L
VOLDOWN
SQL
CH/WX
UP
DOWN
16
AFMS
R252
33 k
R283
33
PTT
C252
0.001
8
7
6
5
DS246
L3-0015TAY-1
R371
100 k
BPFS
V5VS
T5VS
R271
33 k
IC260
TC4W66F
DETO 1
DETIN 2
MICM 3
4
C288
0.047
C289
220
R372
100 k
100
99
98
97
96
95
94
93
92
91
90
89
88
87
86
85
84
83
82
81
80
79
78
77
76
R255
150 k
CP250
MC250
SKB-2746 LPC
C263
0.01
C379
56 P
R279
820
MIC
R284
10
R373
100 k
VOLIN
R253
2.2 k
C254
0.01
R374
68 k
R274
390 k
R276
180 k
C200
0.01
C257
0.01
10
9
8
7
6
CPU5V
VL1
C1
C2
VL2
VL3
COM0
COM1
COM2
COM3
AVSS
VREF
VCC
SEG0
SEG1
SEG2
SEG3
SEG4
SEG5
SEG6
SEG7
SEG8
SEG9
SEG10
SEG11
SEG12
R375
6.8 k
14
13
12
11
10
9
8
POUT
NC
PWGND
VCC
PREGND
NC
PHASE
VIN
NF
RIPPLE
B
C
CPU5V
TDEC
R250
100 k
C250
0.01
1
2
3
4
5
R277
100 k
IC200
NJM2902V
CPU5V
IC280
TA7368F
LCDS
Q250
UN911H
R202
100 k
C284
0.001
RSSIV
NOISV
R256
18 k
C283
0.1
BATTV
BTYPE
TXMS
R262
1.8 k
TDETV
C260
10
R377
82 k
NOISV
C251
10
VOLIN
BEPST
R379
82 k
RSSIV
R261
3.9 k
R260
12 k
R251
470
R207
27 k
SEG0
SEG1
SEG2
SEG3
SEG4
SEG5
SEG6
SEG7
SEG8
SEG9
SEG10
SEG11
SEG12
5V
R203
1.2 M
CPU5V
R201
15 k
BEEP
C261
0.1
Explanatory notes
+B LINE
TX LINE
RX LINE
MAIN UNIT
11 - 1
UNLK
TEMPV
SDATA
SCK
DAST
PLST
A
TXMS
5V
R2
100 k
CP1
C11
2.2
C10
0.047
C6
0.001
C4
18 P
D1
HVC376BTRF
C2
0.01
Q20
DTC144EUA
C5
15 P
C24
0.1
5V
C36
0.001
C8
2P
C9
2P
R28
180
R27
8.2 k
MOD
R34
470
C35
0.001
R52
4.7 k
C41
0.001
C20
0.001
C21
9P
C22
9P
C27
39 P
C28
0.001
C30
0.001
D22
HVU350B
MOD
RSSIV
NOISV
1
2
3
4
5
6
7
8
34 5
C181
0.1
FCON
C179
120 P
R170
390
OSCIN
OSCOUT
MIXOUT
VCC
IFIN
DEC
FILOUT
FILIN
MIXIN
GND
N-REC
N-DET
RSSI
IFOUT
QUAD
AFOUT
RX : 3.57V
R65
150 k
PCON
L55
31 nH
L56
L57
8.5 nH 22 nH
C72
0.001
5
1
L81
C80
0.001 30 nH
L82
32 nH
C84
11 P
C89
7P
C56
0.01
C57
0.1
2
R380
15 k
C81
18 P
C71
30 P
C70
91 P
C83
22 P
C82
18 P
C171
82 P
16
15
14
13
12
11
10
9
R172
470
R120
2.2 k
C150
0.001
C110
0.001
C120
0.01
C109
470 P
D91
RB706F
R382
2.7 k
R70
15 k
C60
0.001
R171
1.2 k
C108
47 P
RX : 4.20V
C153
0.001
X170
CDBC450CX24
C152
0.022
R151 L150
3.3 k 0.82µH
R121
10 k
C151
56 P
R93
1k
L121
56 nH
L122
4.7µH
C123
10 P
L120
82 nH
C121
0.001
C122
15 P
1st Lo
L130
82 nH
C133
13 P
RX : 0.79V
C131
12 P
C130
5P
C132
33 P
C107
0.01
C102 L94
12 P 80 nH
C104
47 P
C64
0.001
C380
0.001
C66
0.01
R74
10 k
R95
100
L91 C94
82 nH 12 P
C96
12 P
C97
1P
C92
47 P
D92
MA77
R90
10 k
C100
12 P
R91
1k
Q90
2SC4226 R25
C106
470 P
C99
2P
R383
12 k
R94
33 k
C105
0.001
L95
0.1µH
C160
0.0056
5W TX : 2.29V
1W TX : 0.65V
L92
82 nH
C95
33 P
C93
4P
D353
MA728
R115
47
[M31]
C115
0.001
[M31]
R81
22 k
C87
0.5 P
L90
50 nH
C91
10 P
C90
9P
T5V
C98
0.001
VCC
C101
33 P
C103
5P
D93
MA728
VCC
L93
80 nH
7.5 V
VCC
CP241
C174
0.001
T5V
5V
VCC
Power Save OFF : 5.00V
RX : 0.91V
SQLO
VOLO
R134
120
R133
10 k
C141
5P
C139
33 P
L132
80 nH
L131
82 nH
R385 1 k
24
23
22
21
20
19
18
17
16
15
14
13
C159
0.01
R156
470
R154
100 k
C158
0.001
RX : 1.45V
C156
0.001
Q151
2SC2714 Y
C193
0.01
R153
1.5 k
FI151
FL-363
C224
22
BPFS
FI150
21R15AB
C135
0.001
C155
6P
R132
10 k
C220
22
C136
0.001
R220
10 k
R222
10 k
R224
10 k
R221
4.7 k
R223
4.7 k
R225
4.7 k
C221
0.01
C222
0.01
C223
0.01
R226
2.2 k
1
CTRL
2
GND
3
NB
4
Q224
XP6501 AB
Q222
2SA1588 GR
R152
1.5 k
C157
0.022
R131
1k
SQLI
SQLO
BEPST
BEEP
Q221
2SA1588 GR
5
6
R155
1.5 k
Q220
2SA1588 GR
AFV
VCC
TX : 4.93V
C225
0.22
R228
22 k
C227
22
C226
0.01
VIN
VOUT
4.98V
5
4
R230
27 k
IC220
NJM2870F05
R235
330 k
R233
2.2 k
Back-Light ON :
3.82V
Back-Light ON :
3.91V
DS240
FY1101F-TR
DS242
SML-311YT
DS244
SML-311YT
DS241
FY1101F-TR
DS243
SML-311YT
DS245
SML-311YT
Q231
XP6501 AB
Q240
DTC144EUA
CP245
CPU5V
C228
0.001
C229
0.001
R231
1M
C230
10
Q223
DTC144EU
C231
1
R232
1K
C232
0.1
R245
1k
C233
0.01
R234
3.3 k
R236
150 k
AFV
LEDS
BPFS
5V
BEEP
AFV
B
C
AFV
AFV
CPU5V
CPU5V
CPU5V
BATTV
VIN8
VOUT8
VOUT7
VIN7
GND
RESET
VDAREF
DO
VIN6
VOUT6
VOUT5
VIN5
RX : 4.96V
Q230
2SB1132 Q
AFVS
VIN1
VOUT1
VPUT2
VIN2
VDD
LD
CLK
DI
VIN3
VOUT3
VOUT4
VIN4
5V
Power Save OFF : 4.96V
3
1
2
3
4
5
DAST 6
7
SCK
SDATA 8
9
MCON 10
BEPO 11
BEEP 12
FCON
PCON
Q225
2SB1132 Q
R227
10 k
IC190
M62363FP-650C
R193
470
R5V
C194
0.01
5V
R192
390
C143
0.001
D130
MA77
R130
10 k
R242
680
R241
680
R240
100
AF Mute OFF :
7.48V
LEDS
BEPST
T5V
5V
C134
1P
4
C137
2P
5
C138
13 P
V5V
R5V
C154
0.001
C140 L133
12 P 80 nH
3
C142
12 P
6
Q150
3SK299
VOLIN
CP240
BPFS
2
C175
0.001
GND
C240
0.001
1
C176
0.001
T5VS
C177
0.1
TDETV
R82
10 k
C88
0.001
D80
RB706F
D90
1SV307
CH16 RX : 4.96V
CH88 RX : 0.00V
DET
BEPST
R80
82 k
C86
9P
C85
24 P
R75
100
R68
100
C59
470 P
R381
10 k
R96
220
R5V
R150
100
C180
120 P
DET
CP80
ANT
C65
100 P
R73
1k
4
C74
0.001
D52
1SV307
R69
15 k
IC50
NJM2125F
L80
50 nH
L58
2.7 µH
R174
220 k
R175
47 k
+
C73
0.001
R71
100
R67
100 k
T5V
D51
MA77
C44
0.001
R36
1k
R5V
C170
0.001
DET
C178
0.22
BEPO
BEEP
C68
47 P
C75
22 P
5W TX : 3.02V
1W TX : 2.33V
C58
0.1
C55
24 P
C43
22 P
R5VS
5V
SDATA
SCK
DAST
MODC
PCON
R176
6.8 k
C67
470 P
RX 3.21V
IC170
TA31136FN
R173
1.5 k
C63
470 P
3
R5V
R194
100 k
R57
82
C53
0.001
R66
47 k
RSSIV
NOISV
FI170
CFWM450E
1
2
L53
18 nH
MP50
PCON
MODC
PCON
MODC
R72
47
Q53
RD01MUS1
L51
82 nH
R56
1.2 k
2nd Lo
C192
10
C51
22 P
R50
1k
Q25
2SC4215 Y
C62
0.001
Q54
RD07MVS1
R384
2.2 k
D23
HVU350B
C61
33
C54
15 P
L25
0.1µH
R35
68 k
C42
5P
C12
0.001
R100
1
Q24
2SC4215 Y
C34
1.5 P
R25
100 k
EP3
Q50
2SC4226 R25
D50
MA77
Q22
2SC4226 R25
C381
0.001
R386
10 k
C40
15 P
C39
12 P
C33
220 P
EP2
T5V
L24
0.1µH
C38
0.001
Q23
2SC4215 Y
Q21
2SC4226 R25
D20
MA2S077
R24
100 k
R33
39 k
L23
0.1µH
R26
8.2 k
D21
MA77
R20
100
L1
6.8µH
C7
0.01
R30
68 k
R76
150
Q351
DTA144EUA
L50
0.1µH
R55
3.3 k
2
UNLK
R29
390
C26
47 P
L20
82 nH
20
19
18
17
16
15
14
13
12
11
C52
0.001
1
PLST
SCK
SDATA
GND1
IN2
VCC2
XB
XI
XO
GND2
CP2
FI2
FO2
VCC1
IN1
ENB
CLK
DATA
T1
LOK
CP1
FI1
FO1
C25
0.001
R23
1k
IC1
µPD3140GS
1
2
3
4
5
6
7
8
9
10
C31
0.001
C32
1.5 P
L22
80 nH
C37
0.3 P
R5
330
R54
33
5VS
CPU5V
R53
100
C50
0.001
X1
CR-766
C3
220 P
R4
47 k
R3
FCON 10 k
V5V
R32
390
R31
680
C29
0.001
L21
2.7µH
R22
560
B
C
V5V
AFV
CPU5V
Explanatory notes
MAIN UNIT
11 - 2
+B LINE
TX LINE
RX LINE
COMMON LINE
TXMS
C1
0.1
MP20
1
2
3
R10
2.2 k
VCC
T5V
T5V
T5V
R7
47 k
T5V
VCC
TEMPV
R6
1k
R9
10
R8
1k
3.58V
TDETV
R1
47 k
VCO CIRCUIT
BTYPE
5V
C191
0.01
V5VS
5V
DET
MOD
RSSIV
VOLIN
BEPST
NOISV
BEPO
BEEP
VOLO
AFV
1-1-32, Kamiminami, Hirano-ku, Osaka 547-0003, Japan
Phone : +81 (06) 6793 5302
Fax
: +81 (06) 6793 0013
URL : http://www.icom.co.jp/world/index.html
Icom America Inc.
Icom (Europe) GmbH
<Corporate Headquarters>
2380 116th Avenue N.E., Bellevue, WA 98004, U.S.A.
Phone : +1 (425) 454-8155
Fax : +1 (425) 454-1509
URL : http://www.icomamerica.com
E-mail : [email protected]
<Customer Service>
Phone : +1 (425) 454-7619
Communication Equipment
Himmelgeister Str. 100, D-40225 Dusseldorf, Germany
Phone : +49 (0211) 346047
Fax : +49 (0211) 333639
URL : http://www.icomeurope.com
E-mail : [email protected]
Icom Canada
Glenwood Centre #150-6165
Highway 17 Delta, B.C., V4K 5B8, Canada
Phone : +1 (604) 952-4266
Fax : +1 (604) 952-0090
URL : http://www.icomcanada.com
E-mail : [email protected]
Icom (Australia) Pty. Ltd.
A.B.N. 88 006 092 575
290-294 Albert Street, Brunswick, Victoria, 3056, Australia
Phone : +61 (03) 9387-0666
Fax : +61 (03) 9387-0022
URL : http://www.icom.net.au
E-mail : [email protected]
Icom New Zealand
146A Harris Road, East Tamaki,
Auckland, New Zealand
Phone : +64 (09) 274 4062
URL : http://www.icom.co.nz
E-mail : [email protected]
Icom Spain S.L
Crta. de Gracia a Manresa Km. 14,750
08190 Sant Cugat del Valles Barcelona, SPAIN
Phone : +34 (93) 590 26 70
Fax : +34 (93) 589 04 46
URL : http://www.icomspain.com
E-mail : [email protected]
Icom (UK) Ltd.
Unit 9, Sea St., Herne Bay, Kent, CT6 8LD, U.K.
Phone : +44 (01227) 741741
Fax : +44 (01227) 741742
URL : http://www.icomuk.co.uk
E-mail : [email protected]
Icom France S.a
Zac de la Plaine, 1, Rue Brindejonc des Moulinais
BP 5804, 31505 Toulouse Cedex, France
Phone : +33 (5) 61 36 03 03
Fax : +33 (5) 61 36 03 00
URL : http://www.icom-france.com
E-mail : [email protected]
Asia Icom Inc.
Fax : +64 (09) 274 4708
6F No.68, Sec. 1 Cheng-Teh Road, Taipei, Taiwan, R.O.C.
Phone : +886 (02) 2559 1899
Fax : +886 (02) 2559 1874
URL : http://www.asia-icom.com
E-mail : [email protected]
Beijing Icom Ltd.
Icom Polska
1305, Wanshang Plaza, Shijingshan Road, Beijing China
Phone : +86 (010) 6866 6337
Fax : +86 (010) 6866 3553
URL : http://www.bjicom.com
E-mail : [email protected]
Sopot, 3 Maja 54 Poland
Phone : +48 (58) 550 7135
Fax : +48 (58) 551 0484
E-mail : [email protected]
1-1-32, Kamiminami, Hirano-ku, Osaka 547-0003, Japan
S-14008MZ-C2
© 2003 Icom Inc.