No category

Download Icom IC-GM1600 User's Manual

Transcript

SERVICE
MANUAL
SURVIVAL CRAFT 2-WAY RADIO
INTRODUCTION
This service manual describes the latest service information
for the IC-GM1600/E VHF MARINE TRANSCEIVER at the
time of publication.
MODEL
VERSION
USA
GEN
EUR
UK
IC–GM1600
IC–GM1600E
TX Hi-POWER
2W
2W
2W
2W
To upgrade quality, all electrical or mechanical parts and
internal circuits are subject to change without notice or
obligation.
DANGER
NEVER connect the transceiver to an AC outlet or to a DC
power supply that uses more than 7.5 V. Such a connection
could cause a fire or electric hazard.
DO NOT reverse the polarities of the power supply when
connecting the transceiver.
DO NOT apply an RF signal of more than 20 dBm (100 mW)
to the antenna connector. This could damage the transceiver's front end.
ORDERING PARTS
Be sure to include the following four points when ordering
replacement parts:
1.
2.
3.
4.
10-digit order numbers
Component part number and name
Equipment model name and unit name
Quantity required
<SAMPLE ORDER>
5030002790 LCD
A0286
IC-GM1600 Main unit 5 pieces
8810009510 Screw BO 2x4 NIxZU (BT) IC-GM1600E Chassis 10 pieces
Addresses are provided on the inside back cover for your
convenience.
REPAIR NOTES
1.
2.
3.
4.
5.
6.
7.
Make sure a problem is internal before disassembling the transceiver.
DO NOT open the transceiver until the transceiver is disconnected from its power source.
DO NOT force any of the variable components. Turn them slowly and smoothly.
DO NOT short any circuits or electronic parts. An insulated turning tool MUST be used for all adjustments.
DO NOT keep power ON for a long time when the transceiver is defective.
DO NOT transmit power into a signal generator or a sweep generator.
ALWAYS connect a 30 dB to 40 dB attenuator between the transceiver and a deviation meter or spectrum analyzer when
using such test equipment.
8. READ the instructions of test equipment thoroughly before connecting equipment to the transceiver.
Icom, Icom Inc. and
logo are registered trademarks of Icom Incorporated (Japan) in the United States, the United
Kingdom, Germany, France, Spain, Russia and/or other countries.
TABLE OF CONTENTS
SECTION
1
SPECIFICATIONS
SECTION
2
INSIDE VIEWS
SECTION
3
DISASSEMBLY INSTRUCTIONS
SECTION
4
CIRCUIT DESCRIPITON
SECTION
4-1
RECEIVER CIRCUITS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-1
4-2
TRANSMITER CIRCUITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-2
4-3
PLL CIRCUITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-3
4-4
POWER SUPPLY CIRCUITS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-4
4-5
PORT ALLOCATIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-4
5
ADJUSTMENT PROCEDURES
5-1
PREPARATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-1
5-2
SOFTWARE ADJUSTMENTS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-4
SECTION
6
PARTS LIST
SECTION
7
MECHANICAL PARTS AND DISASSEMBLY
SECTION
8
SEMICONDUCTOR INFORMATION
SECTION
9
BOARD LAYOUTS
SECTION
SECTION
9-1
MAIN UNIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9-1
9-2
VR BOARD . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9-3
9-3
MIC BOARD. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9-3
9-4
BC-158. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9-3
10 BLOCK DIAGRAM
11 VOLTAGE DIAGRAM
11-1
MAIN UNIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11-1
11-2
VR / MIC BOARD . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11-3
SECTION 1
SPECIFICATIONS
• Frequency coverage
IC-GM1600
IC-GM1600/E
[USA]
[GEN], [EUR], [UK]
TX
156.025–157.425 MHz [ON-BOARD]
156.000–161.450 MHz [ON-BOARD]
RX
156.050–163.275 MHz [ON-BOARD]
156.000–163.425 MHz [ON-BOARD]
TX/RX
156.300–156.875 MHz [SURVIVAL]
GENERAL
• Number of programable channels
• Type of emission
100 channels
16K0G3E
16K0G3E (for ATIS)
50 Ω (nominal)
• Antenna impedance
• Operating temperature range
−4˚F to +140˚F
• Power supply requirement
–20˚C to +55˚C
7.5 V DC nominal (negative ground)
RX
• Current drain (approx.)
TX
2W
1.0 A
1W
0.7 A
65(W) × 145(H) × 44(D) mm; 2 9/16(W) × 5 23/32(H) × 1 3/4(D) in.
• Dimensions (projections not included)
• Weight (approx.)
• Output power
385 g; 13.58 oz. (Including BP-234)
High
2W
Low
1W
• Modulation
Variable reactance frequency modulation
TRANSMITTER
• Max. frequency deviation
± 5.0 kHz
• Frequency error
±5.0 ppm
±1.5 kHz
• Spurious emissions
–70 dBc typ.
0.25 µW (30 MHz to 1 GHz)
1.00 µ W (1 GHz–2 GHz)
• Adjacent channel power
70 dB
• Audio harmonic distortion
10% (at 60% deviation)
• FM hum and noise
40 dB
–
• Residual modulation
–
40 dB
• Audio frequency response
+1 dB to –3 dB of 6 dB oct. from 300 Hz to 3000 Hz
• Limiting charact. of modulation
60–100% of max. deviation
• Microphone impedance
2 kΩ
• Receive system
Double conversion superheterodyne system
• Intermediate frequencies
1st : 31.05 MHz, 2nd : 450 kHz
0.25 µV typ. at 12 dB SINAD
–2 dBµ emf typ. at 20 dB SINAD
• Squelch sensitivity
–6dBµ typ. (at threshold)
–2 dBµ emf typ. (at threshold)
• Adjacent channel selectivity
70 dB typ.
70 dB
• Spurious response
70 dB typ.
70 dB
• Intermodulation rejection ratio
70 dB typ.
68 dB
• Sensitivity
RECEIVER
7.2 V DC nominal (negative ground)
0.2 A (at max. audio)
• Hum and Noise
40 dB
• Audio frequency response
+1 dB to –3 dB of 6 dB oct.
(from 300 Hz to 3000 Hz)
+1 dB to –3 dB of –6 dB oct.
(from 300 Hz to 3000 Hz)
• Audio output power
(at 10% distortion with an 8 Ω load)
0.35 W typ.
0.2 W typ.
8Ω
• Output impedance (audio)
Specifications are measured in accordance with TIA/EIA–603 and FCC PARTS 80.271 (IC-GM1600), and IEC61097–12 (IC-GM1600E).
All stated specifications are subject to change without notice or obligation.
1-1
• CHANNEL LISTS
• International channels
Frequency (MHz)
CH
Transmit
Receive
01
156.050
160.650
02
156.100
03
156.150
04
CH
Frequency (MHz)
Transmit
Receive
11
156.550
156.550
160.700
12
156.600
160.750
13
156.650
156.200
160.800
14
05
156.250
160.850
06
156.300
156.300
07
156.350
160.950
08
156.400
156.400
18
09
156.450
156.450
19
10
156.500
156.500
CH
Frequency (MHz)
Transmit
Receive
21
157.050
161.650
156.600
22
157.100
156.650
23
157.150
156.700
156.700
24
15*1 156.750
156.750
25
CH
Frequency (MHz)
Transmit
Receive
61
156.075
160.675
161.700
62
156.125
161.750
63
156.175
157.200
161.800
64
157.250
161.850
65
CH
Frequency (MHz)
Transmit
Receive
71
156.575
156.575
160.725
72
156.625
160.775
73
156.675
156.225
160.825
74
156.275
CH
Frequency (MHz)
Transmit
Receive
81
157.075
161.675
156.625
82
157.125
161.725
156.675
83
157.175
161.775
156.725
156.725
84
157.225
161.825
160.875
75*3 156.775
156.775
85
157.275
161.875
161.925
156.800
156.800
26
157.300
161.900
66
156.325
160.925
76*3 156.825
156.825
86
157.325
17*1 156.850
156.850
27
157.350
161.950
67
156.375
156.375
77
156.875
156.875
87
157.375
157.375
156.900
161.500
28
157.400
162.000
68
156.425
156.425
78
156.925
161.525
88
157.425
157.425
156.950
161.550 37A*2 157.850
157.850
69
156.475
156.475
79
156.975
161.575
P4*2 161.425
161.425
160.625
70† 156.525
156.525
80
157.025
161.625
16
20
157.000
161.600
60
156.025
†
Receive only
*1 Channels 15 and 17 may also be used for on-board communications provided the effective radiated power does not exceed 1 W,
and subject to the national regulations of the administration concerned when these channels are used in its territorial waters.
*2 UK Marina Channels: M1=37A (157.850 MHz), M2=P4 (161.425 MHz) for U.K. version only
*3 The use of these channels should be restricted to navigation-related communications only and all precautions should be taken to
avoid harmful interference to channel 16, e.g. by limiting the output power to 1 W or by means geographical separation.
• USA channels (for U.K. version only)
Frequency (MHz)
CH
Transmit
01A 156.050
Receive
CH
Frequency (MHz)
Transmit
Receive
CH
Frequency (MHz)
Transmit
Receive
CH
Frequency (MHz)
Transmit
Receive
156.050
12
156.600
156.600
22A 157.100
157.100
64A 156.225
156.225
23A 157.150
CH
77
Frequency (MHz)
Transmit
Receive
156.875
156.875
CH
86
Frequency (MHz)
Transmit
Receive
157.325
161.925
---
13† 156.650
156.650
157.150
65A 156.275
156.275
78A 156.925
156.925
156.150
14
156.700
156.700
24
157.200
161.800
66A 156.325
156.325
79A 156.975
156.975
---
15† 156.750
156.750
25
157.250
161.850
67† 156.375
156.375
80A 157.025
157.025
87A 157.375
157.375
156.250
16
156.800
156.800
26
157.300
161.900
68
156.425
156.425
81A 157.075
157.075
88 157.425
162.025
156.300
156.300
17† 156.850
156.850
27
157.350
161.950
69
156.475
156.475
82A 157.125
157.125
88A 157.425
157.425
07A 156.350
156.350
18A 156.900
156.900
28
157.400
162.000
70‡ 156.525
156.525
83A 157.175
157.175
P4* 161.425
161.425
19A 156.950
156.950
37A* 157.850
157.850
71
156.575
156.575
161.600
61A 156.075
156.075
72
156.625
156.625
---
73
156.675
156.675
156.175
74
156.725
156.725
--
---
03A 156.150
--
---
05A 156.250
06
08
156.400
156.400
09
156.450
156.450
20
157.000
10
156.500
156.500
20A 157.000
157.000
11
156.550
156.550
21A 157.050
157.050
† Low
--
---
63A 156.175
157.225
161.825
84A 157.225
84
157.225
157.275
161.875
85A 157.275
85
157.275
86A 157.325
87
157.375
157.325
161.975
power only
‡
Receive only
*UK Marina Channels: M1=37A (157.850 MHz), M2=P4 (161.425 MHz) for U.K. version only
• Survival operation channels
TX/RX
Channel number
Channel number
TX/RX
Channel number
TX/RX
06
156.300 MHz
08
156.400 MHz
09
156.450 MHz
10
156.500 MHz
11
156.550 MHz
12
156.600 MHz
13
156.650 MHz
14
156.700 MHz
15*
156.750 MHz
16
156.800 MHz
17*
156.850 MHz
67
156.375 MHz
68
156.425 MHz
69
156.475 MHz
71
156.575 MHz
72
156.625 MHz
73
156.675 MHz
74
156.725 MHz
77
156.875 MHz
*U.S.A. version is low power only
1-3
SECTION 2
INSIDE VIEWS
• MAIN UNIT
TOP VIEW
BOTTOM VIEW
Antenna
Switches
*D131, D151: 1SV307
D152: MA2S077
S5V Regulator
(Q561: 2SA1588)
T5V Regulator
(Q323: 2SA1588)
IF amplifier
(Q211: 2SC4215)
Power amplifier
(*Q111: RD07MVS1)
Pre-drive
(*Q101: RD01MUS1)
RF amplifier
R5 Regulator
(Q165: 3SK294)
(Q322: 2SA1588)
TX/RX swith
(D91, D92: MA77)
VCO circuits
D/A converter IC
(IC251: M62363FP-657C)
CPU
IC661: PD78F0338
GC-9EB
EEPROM
(IC591: BR24L32FV-W)
*Located in under the plate.
Reset IC
(IC581: S-80942CNMC)
2-1
SECTION 3
DISASSEMBLY INSTRUCTIONS
• REMOVING THE REAR PANEL
1
2
3
4
5
Remove the speaker panel A.
Unscrew 2 screws B, and remove 2 washers C.
Unscrew 2 screws D.
Unscrew 2 screws E, and remove 2 washers F.
Remove the rear panel and the main seal from the front
panel.
Note: When replacing the screws, 10–12 kg of torque MUST
be applied to ensure water resistance.
B
C
Rear panel
D
-)#30
Main seal
Front panel
F
E
A
R 7!2.).'.%6%2ATTEMPTTOREMOVETHESPEAKERPANEL
USINGYOURFINGERNAILSTHISMAYRESULTINJURLY
5SEAFLATHEADSCREWDRIVERORASIMILAR
FLATINSTRUMENT
• REMOVING THE MAIN UNIT
• REMOVING THE CHASSIS UNIT
1 Unscrew 9 screws L.
2 Unsolder 2 points M, and take off the main unit in the
direction of the arrow.
1
2
3
4
Unscrew 1 nut G.
Unscrew 2 screws H.
Take off the chassis unit in the direction of the arrow.
Unplug the connector I and the cable J from the
chassis unit.
5 Remove 1 washer K.
Chassis unit
K
F
L
L
H
L
G
Main unit
M
I
Front panel
Chassis unit
3-1
SECTION 4
CIRCUIT DESCRIPTION
The 1st IF signal from the 1st mixer is passed through the
crystal filter (FI211) to suppress unwanted signals, and
amplified at the 1st IF amplifier (Q211).
4-1 RECEIVER CIRCUITS
4-1-1 ANTENNA SWITCHING CIRCUIT
The antenna switching circuit toggles receive line and
transmit line. This circuit does not allow transmit signals to
enter the receiver circuits.
The amplified 1st IF signal is applied to the FM IF IC
(IC231).
Received signals from the antenna are passed through the
low-pass filter (LPF: L131, L132, C131–C136) and applied
to the antenna switching circuit (D151, D152).
4-1-4 2nd IF AND DEMODULATOR CIRCUITS
The 1st IF signal is converted into the 2nd IF signal and
de-modulated by the FM IF IC. The FM IF IC contains
2nd mixer, limiter amplifier, quadrature detector, etc. in its
package.
While receiving, no voltage is applied to D151 and D152.
Thus, the receive line and the ground are disconnected and
L151, L152, C151, C152 and C153 function as an LPF which
leads received signals to the RF circuits.
The 1st IF signal from the 1st IF amplifier is applied to pin
16 of IC231, and mixed with the 30.6 MHz 2nd LO signal
coming from the doubler (Q221), to convert into the 450 kHz
2nd IF signal and output from pin 3. The 2nd IF signal is
filtered by the ceramic filters (FI231, FI232) to suppress the
heterodyne noise, then applied to IC231 (pin 5) again and
amplified at the limiter amplifier section and demodulated by
the quadrature detector.
4-1-2 RF CIRCUITS
The RF circuits amplify signals within the range of frequency coverage and filters off out-of-band signals.
The signals from the antenna switching circuit are passed
through the two-stage tunable bandpass filter (BPF: D154,
D155, L154–L156, C156, C157, C159–C161, C163, C164,
C168), then applied to the RF amplifier (Q165).
The quadrature detector is a detection method which uses a
ceramic discriminator (X231). The demodulated AF signals
are output from pin 9.
The amplified signals are passed through another two-stage
BPF (D181, D182, L166, L181 C181, C182, C184–C186,
C188) to suppress unwanted signals. The filtered signals are
then applied to the 1st mixer circuit.
4-1-5 AF CIRCUITS
Demodulated signals are filtered and amplified at the AF
circuits.
4-1-3 1st MIXER AND 1st IF AMPLIFIER CIRCUITS
AF signals from IC231 (pin 9) are passed through the AF
mute switch (IC281 A; pins 1, 2), analog switch (IC282; pins
1, 7), LPF (IC261 C; pins 8–10) and R801 (VR BOARD) to
control the AF output level.
The 1st mixer circuit converts received signals into the
1st intermediate frequency (IF) signal by mixing with local
oscillator (LO) signal. The converted 1st IF signal is filtered
at the 1st IF filter, then amplified at the 1st IF amplifier.
The level controlled AF signals are passed through the AF
mute switch (Q411) and the de-emphasis circuit (R411,
C413) to obtain the frequency characteristic of –6 dB/oct.
The signals from the two-stage BPF are converted into the
31.05 MHz 1st IF signal at the 1st mixer (Q191) by being
mixed with the 1st LO signals generated at RX VCO (Q41,
D31–D34).
The de-emphasized signals are applied to the AF power
amplifier (IC421, pin 4). The AF power amplifier provides
more than 0.3 W of audio power.
• 2nd IF AND DEMODULATER CIRCUITS
450 kHz 2nd IF filters
FI232
"SQCON" signal
from the D/A converter (IC251)
FI231
8
7
W/N
SW
D232
D231
30.6 MHz 2nd LO signal
3
5
Noise
AMP
Active
filter
W/N
SW
2
×2
Noise
detector
2
PLL
IC
(IC1)
1
Q221
Limiter
AMP
15.3 MHz
Noise
Mixer
comparator
FM
detector
IC231 TA31136FN
9
10
11
14
16
1st IF signal
from the IF amplifier (Q211)
"NOISV" signal to the CPU (IC661, pin 32)
AF "DET" signal
to the AF circuits
R5V
X231
4-1
X1
4-1-6 SQUELCH CIRCUIT
4-2-2 MODULATOR CIRCUIT
Squelch circuit mutes AF output signal when no signals are
received.
The modulation circuit modulates the VCO oscillating signal
with the audio signals from the microphone.
A portion of the AF signals from the FM IF IC (IC231, pin 9) are
applied to the IC251 to control the level, and the active filter
(R239–R241, C237, C238). The filtered signals are applied to
the noise amplifier section in the FM IF IC (IC231, pin 8) to
amplify the noise components only.
AF signals from the D/A converter (IC251, pin 3) are applied
to the modulation circuit (D39) to modulate the oscillated
signal by changing the reactance of D39 at the TX VCO (Q51,
D35–38).
The amplified noise components are detected at the noise
detector section, and output from pin 14 as the "NOISV"
signal to the CPU (IC661, pin 32). Then the CPU outputs
"AFMS" signal from pin 84 according to the "NOISV" signal
level to control the AF mute switch (Q411).
4-2-3 TRANSMIT AMPLIFIERS
Transmit amplifiers amplify the TX VCO output to transmit
power level.
The TX VCO output signal is buffer-amplified by the buffer
amplifiers (Q61, Q62) and passes through the TX/RX switch
(D91). The signals from the TX/RX switch are applied to the
another buffer amplifier (Q91), pre-drive (Q101) and power
amplifier (Q111) and amplified to the transmit level.
4-2 TRANSMITTER CIRCUITS
4-2-1 MIC AMPLIFIER, SPLATTER FILTER CIRCUITS
The power amplifier output is applied to the antenna
connector (J41: CHASSIS UNIT) via the antenna switching
circuit and the LPFs.
The MIC amplifier circuit amplifies audio signals from the
microphone within +6 dB/oct pre-emphasis characteristics
and amplifies to the level needed for modulation.
The AF signals from the microphone are passed through
the microphone switch (Q461) and the microphone mute
switches (IC682 A, pins 1, 2; IC682 B, pins 5, 6). The AF
signals are then passed through the pre-emphasis circuit
(R463, C463) to obtain frequency characteristics of +6 dB/oct.
4-2-4 APC CIRCUIT
The APC (Automatic Power Control) circuit stabilizes
transmit output power and controls transmit output power
High, Middle and Low.
The RF output signal from the power amplifier (Q111)
is detected at the power detector (D121). The detector
converts the RF signals into DC voltage, and the detected
voltage is applied to the APC amplifier (IC141, pin 3).
The pre-emphasized AF signals are amplified at the
microphone amplifier (IC261 B), and adjusted its level at the
microphone gain control circuit (Q653, Q654, R474, R705,
R707, R708). The level adjusted signals are applied to the
limiter amplifier (IC491 A; pins 1, 2) to limit its level via the
AF mute switch (IC481 A; pins 1, 2).
The transmit output power setting voltage is applied to
another input terminal of the APC amplifier (IC141, pin 1) as
the reference voltage. The APC amplifier controls the bias of
the buffer, pre-drive and power amplifiers by comparing the
detected voltage and reference voltage. Thus the APC circuit
maintains a constant output power.
The AF signals are then passed through the splatter filter
(IC491 B; pins 6, 7) to suppress unwanted 3 kHz and higher
audio signals, then applied to the modulation circuit via the
D/A converter (IC251; pins 3, 4).
Another power detector (D132) detects the RF output level
and outputs "TDETV" signal to the CPU (IC661, pin 31). The
CPU outputs "TLED" signal to the LED driver (Q655) to light
TX LED (DS655).
• APC CIRCUIT
VCC
T5V
Q91
Buffer
AMP
RF signals
from TX/RX SW
T1CON
1+
Q101
Predrive
Q111
Power
AMP
LPF
ANT
SW
LPF
To ANT
IC141
APC
AMP
4
D121
D132
3 –
TDETV
4-2
The phase detector compares the input signal with a
reference frequency, and then outputs the control signal
(pulse-type) from pin 5. The pulse-type signal is converted
into DC voltage at the loop filter (R17–R19, C16, C17), and
then applied to the RX VCO (Q41, D31–D34) as the lock
voltage.
4-3 PLL CIRCUITS
4-3-1 GENERAL
PLL circuits control TX and RX VCO circuits. IC1 is a
PLL IC and contains prescaler, programmable counter,
programmable divider, phase detector, charge pump in its
package.
The VCOs directly generate the transmit frequency and the
1st LO frequency for receiving. The PLL sets the divided
ratio based on the serial data from the CPU (IC661), and
compares the phase of the VCO output with the reference
oscillator's frequency (15.3 MHz) oscillated by X1.
If the oscillated signal drifts, the phase of its frequency
changes from the phase of the reference frequency, causing
a lock voltage change to compensate for the drift in the
oscillated frequency.
4-3-2 TRANSMIT LOOP
A portion of the generated signal at the TX VCO (Q51, D35–
D39) is applied to the PLL IC (IC1, pin 8) via buffer-amplifier
(Q71). The applied signal is divided at the prescaler section
and programmable divider section and is then applied to the
phase detector section.
The phase detector compares the input signal with the
reference frequency, and then outputs the control signal
(pulse-type) from pin 5 via the charge pump section. The
pulse-type signal is converted into DC voltage at the loop
filter (R17–R19, C16, C17), and then applied to the TX VCO
(Q51, D35–D39) as the lock voltage.
4-3-3 RECEIVE LOOP
The generated signal at the RX VCO (Q41, D31–D34) is
applied to the PLL IC (IC1, pin 8) via buffer-amplifier (Q71)
and is divided at the prescaler section and programmable
divider section and is then applied to the phase detector
section.
• PLL CIRCUITS
RX VCO
D92
Buffer
Q62
Q41, D31–D34
Buffer
Q3
"LOINV" signal
to the CPU (IC661, pin 34)
D91
Buffer
Q61
TX VCO
to 1st mixer circuit
to transmitter circuit
Buffer
Q71
Q51, D35–D39
Loop
filter
LPF
IC1 MB15A02PFV
5
Charge
pump
Programmable
divider
Prescaler
8
9
Phase
detector
30.6 MHz 2nd LO
signal to the FM IF IC
(IC231, pin 2)
×2
Shift register
2
10
11
1
Q221
4-3
SCLK
SDATAO
PLSTBO
PLL control signals
from D/A converter (IC251, pins 6–7)
15.3 MHz reference signal
from reference frequency osciilator (X1)
4-4 POWER SUPPLY CIRCUITS
4-4-1 VOLTAGE LINES
LINE
VCC
DESCRIPTION
The voltage from the connected DC power
supply passed through the [VOL] switch (R1:
VR BOARD).
PIN
NUMBER
PORT
NAME
77, 78
LEDS1, LEDS2
80
MICMS
DESCRIPTION
Output port for dimmer control
signal.
Output port for microphone mute
signal.
"HIGH": Microphone mute
Output port for internal speaker
mute signal.
"HIGH": Speaker mute
CPU5V
5V for the CPU (IC661) converted from the
VCC line at the CPU5V regulator circuit (IC551).
81
ISPMS
M5V
Common 5V line converted from the VCC line
at the M5V regulator circuit (Q551–Q553).
84
AFMS
Output port for AF mute signal.
5V for the transmit circuits controlled by the
T5V control circuit (Q323) using the T5VS
signal from the CPU (IC661, pin 90).
85
AFVS
T5V
Output port for AF amplifier power
supply control signal.
102
103
PTTIN
EXPTT
104
BTYPE
105
PTTM
106–108
MIC1–MIC3
109
110
111
112
113
114
115
SQL
UP
DOWN
CH/WX
16/9
SCAN
H/L
117
VOXM
Ouput port for mute signal in VOX
mode.
119
UNLK
Input port for PLL unlock signal.
S5V
5V for the AF circuits controlled by the S5V
control circuit (Q561) using the S5VS signal
from the CPU (IC661, pin 87).
R5V
5V for the receive circuits controlled by the R5V
controll circuit (Q322) using the R5VS signal
from CPU (IC661, pin 89).
4-5 PORT ALLOCATIONS
4-5-1 CPU (IC661)
PIN
NUMBER
PORT
NAME
1
BEEP
3
EXSTB
4
DASTB
5
6
7
10
11
12
13
14
15
17
25
27
PLSTB
ERXDI
ETXDO
SDATA
SCK
ESCK
ESDA
TLED
RLED
CSIFT
RESET
WDECV
28
EXDET
29
VOXT
30
BATTV
31
32
33
34
35
TDETV
NOISV
RSSIV
LOINV
TEMPV
75, 76
CONT1, CONT2
DESCRIPTION
Input port for [PTT] switch.
Input port for external PTT switch.
I n p u t p o r t fo r b a t t e r y t y p e
detection.
Output port for microphone mute
signal.
Output por ts for microphone
sensitivity detection signal.
Input port for [SQL] key.
Input port for [Y] key.
Input port for [Z] key.
Input port for [CALL] key.
Input port for [16] key.
Input port for [CH] key.
Input port for [Hi/Lo] key.
Output port for BEEP signal.
Output port for external expander
strobe signal.
Output port for external D/A strobe
signal.
Output port for PLL strobe.
4-5-2 EXPANDER (IC341)
PIN
NUMBER
PORT
NAME
6
DETMS
11
ATTS
Output port for RF attenuator control
signal.
Output port for serial data.
12
TXMS
Output port for TX mute signal.
Output port for serial clock.
13
VCOS
TX/RX VCO switching signal.
Input port for EEPROM clock.
14
SQLT
Output port for squelch control signal.
Input port for cloning.
Output port for cloning.
I/O port for EEPROM data.
Output port for TX LED driver.
Output port for RX LED driver.
Output port for clock shift signal.
Input port for reset signal.
Input port for WX tone signal.
Input port for the [MIC/SP] detect
signal.
Input port for VOX signal.
Input por t for battery voltage
detection signal.
Input port for TX power level.
Input port for noise level.
Input port for RSSI level.
Input port for PLL lock voltage level.
Input port for temperture level.
Output ports for LCD contrast
control signal.
4- 4
DESCRIPTION
Output port for DET mute signal.
SECTION 5
ADJUSTMENT PROCEDURES
5-1 PREPARATION
REQUIRED TEST EQUIPMENTS
When adjusting IC-GM1600/E, the optional CS-M90/GM1600 ADJ ADJUSTMENT SOFTWARE (Rev. 1.0 or later), OPC-478 (RS-232
type) or OPC-478U (USB type) CLONING CABLE, OPC-1028 and JIG cable (see page 5-2) are required.
EQUIPMENT
GRADE AND RANGE
: 0.1–3 W
: 100–300 MHz
: 50 Ω
: Less than 1.2 : 1
EQUIPMENT
GRADE AND RANGE
RF power meter
(terminated type)
Measuring range
Frequency range
Impedance
SWR
Frequency counter
Frequency range
: 0.1–300 MHz
Frequency accuracy : ±1 ppm or better
Sensitivity
: 100 mV or better
Oscilloscope
Frequency range : DC–20 MHz
Measuring range : 0.01–20 V
FM deviation meter
Frequency range
Measuring range
: 30–300 MHz
: 0 to ±10 kHz
AC millivoltmeter
Measuring range : 10 mV to 10 V
: 300–3000 Hz
: 1–500 mV
External speaker
Audio generator
Frequency range
Output level
Input impedance : 8 Ω
Capacity
: More than 0.3 W
Attenuator
Power attenuation : 20 or 30 dB
Capacity
: More than 5 W
Standard signal
generator (SSG)
STARTING SOFTWARE ADJUSTMENT
(1) Connect IC-GM1600/E and a PC with OPC-478/U,
OPC-1028 and JIG CABLE.
(2) Turn the transceiver ON.
(3) Boot up Windows®, and click the program group 'CS-M90/
GM1600 ADJ’ in the ‘Programs’ folder of the [Start] menu,
then CS-M90/GM1600 ADJ’s window appears.
(4) Click ‘Adjust’ on the CS-M90/GM1600’s window, then
IC-GM1600/E’s up-to-date condition appears.
(5) Set or modify adjustment data as desired.
CAUTION!: BACK UP the originally programmed memory
data in the transceiver before programming
the adjustment frequencies.
When program the adjustment frequencies
into the transceiver, the transceiver’s memory
data will be overwritten and lose original
memory data at the same time.
Microsoft and Windows are registered trademarks of
Microsoft Corporation in the U.S.A. and other countries.
5-1
Frequency range : 0.1–300 MHz
Output level
: 0.1 µV to 32 mV
(–127 to –17 dBm)
• CONNECTION
AC millivoltmeter
Audio generator
OPC-478 (RS-232C type)
to RS-232C port
to the antenna connector Standard signal generator
0.1 µV to 32 mV
(–127 dBm to –17 dBm)
OPC-478U (USB type)
DO NOT transmit while
an SSG is connected to
the antenna connector.
to USB port
PC
Attenuator
20 dB / 30 dB
To CLONE line
(BLACK)
To MIC. line
(WHITE)
RF power meter
0.1–3 W/50 Ω
To red line
(RED)
SINAD meter
FM
deviation meter
Frequency
counter
JIG cable
OPC-1028
Speaker (8 Ω)
To [SP]
connector
IC-GM1600/E
• JIG CABLE
To SINAD meter/speaker
To audio generator/AC millivoltmeter
(MIC. line) WHITE
OPC-478/U
OPC-1028
(SP. line)
(CLONE line)
RED
BLACK
SHIELD
5-2
• PC SCREEN EXAMPLE
I/O check button
q
w
e
r
t
y
i
u
o
NOTE: The above screen is an example.
Each transceiver has its own specific values for each setting.
q: Adjustment condition
y: Receive sensitivity (Manualy)
w: Reference frequency
u: Squelch level
e: RF output power
i: S-meter
r: FM deviation (Wide)
o: VOX
t: Receive sensitivity (Automaticaly)
5-3
5-2 SOFTWARE ADJUSTMENT (FREQUENCY)
Select the adjustment item with [↑] / [↓] keys, then set the value with [←] / [→] keys on the connected PC.
MEASUREMENT
ADJUSTMENT
ADJUSTMENT CONDITION
VALUE
UNIT
PLL LOCK
VOLTAGE
1 • Operating CH. : 16
• Receiving
PC
screen
1.5–3.0 V [USA]
Check the LVIN Data cell's
v a l u e i n t h e I / O c h e c k 1.85–3.35 V [Others]
window.
(Verify)
Click the "I/O check button"
1.4–2.9 V
on the CS-M90/GM1600
ADJ's screen (see page
(Verify)
5-3) to open the I/O check
window as below.
Top
Panel
Loosely couple the frequency
counter to the antenna
conector.
2 • Operating CH. : 16
• RF power
: Low
• Transmitting
REFERENCE
FREQUENCY
[Ref. Freq.]
1 • Operating CH. : 16
• Connect the RF power meter or a 50 Ω
dummy load to the antenna connector.
• RF power
: Low
• Transmitting
OPERATION
156.8000 MHz
±500 Hz
PLL LOCK VOLTAGE
NOTE: The above screen is an example.
Each transceiver has its own specific values.
5-4
5-2 SOFTWARE ADJUSTMENT (TRANSMITTING)
Select the adjustment item with [↑] / [↓] keys, then set the value with [←] / [→] keys on the connected PC.
MEASUREMENT
ADJUSTMENT
ADJUSTMENT CONDITION
VALUE
UNIT
OUTPUT POWER
[RF Power (High)]
1 • Operating CH. : 16
• RF power
: High
• Transmitting
[RF Power (Low)]
2 • Operating CH.
• RF power
• Transmitting
OPERATION
Top Connect the RF power meter to
panel the antenna connector.
: 16
: Low
2.0 W
0.75 W
FM DEVIATION
[MOD (Wide)]
Top Connect the FM deviation meter
1 • Operating CH. : 16
panel to the antenna connector through
• Set the FM deviation meter as;
the attenuator.
HPF
: OFF
LPF
: 20 kHz
De-emphasis : OFF
Detector
: (P±P)/2
• Connect the audio generator to
the [MIC/SP] jack through OPC-1028
and set as;
Frequency
: 1 kHz
Level
: 25 mV rms
• Transmitting
±4.15–4.25 kHz
VOX
[VOX]
1 • Operating CH. : 16
PC Push the [ENTER] key on the keyboad
• Set to VOX mode.
screen of the connected PC.
(Push [SQL] + [Hi/Lo].)
• No audio applied to the [MIC/SP]
jack.
Automatic
adjustment
5-5
5-2 SOFTWARE ADJUSTMENT (RECEIVING)
Select the adjustment item with [↑] / [↓] keys, then set the value with [←] / [→] keys on the connected PC.
ADJUSTMENT
MEASUREMENT
ADJUSTMENT CONDITION
UNIT
RECEIVE
SENSITIVITY
[BPF T1]
[BPF T2]
[BPF T3]
[BPF T4]
VALUE
OPERATION
Top Connect the distortion meter with an 8 Ω
1 • Operating CH. : 16
• C o n n e c t th e s ta n d a rd s i g nal pannel load to the [MIC/SP] jack through the
JIG cable.
generator to the antenna connector
and set as;
Frequency : 156.800 MHz
Level
: +20 dBµ*
Modulation : 1 kHz
Deviation : ±3.0 kHz
• Receiving
Minimum
distortion level
CONVENIENT:
RECEIVE SENSITIVITY can be adjusted automatically.
1. Put the cursor on the [BPF ALL Sweep] on the CS-M90/GM1600 ADJ's screen and push the [ENTER] key.
2. The connected PC tunes BPF T1−T4 to peak level automaticaly.
or
1. Put the cursor on the one of BPF T1−T4 as desired.
2. Push the [ENTER] key to start tuning.
3. Repeat 1 and 2 to perform additional BPF tuning.
SQUELCH
LEVEL
[Noise]
1 • Operating CH. : 16
• C o n n e c t th e s ta n d a rd s i g nal
generator to the antenna connector
and set as;
Frequency : 156.800 MHz
Level
: –5 dBµ* [USA]
–6 dBµ* [Others]
Modulation : 1 kHz
Deviation : ±3.0 kHz
• Receiving
Top
panel
Push the [ENTER] key on the keyboad
of the connected PC.
Automatic
adjustment
S-METER
[RSSI]
1 • Operating CH. : 16
• C o n n e c t th e s ta n d a rd s i gnal
generator to the antenna connector
and set as;
Frequency : 156.800 MHz
Level
: –5 dBµ* [USA]
–4 dBµ* [Others]
Modulation : 1 kHz
Deviation : ±3.0 kHz
• Receiving
Top
panel
Push the [ENTER] key on the keyboad
of the connected PC.
Automatic
adjustment
*The output level of the standard signal generator (SSG) is indicated as the SSG's open circuit.
5-6
SECTION 6
PARTS LIST
• IC-GM1600/E
[MAIN UNIT]
REF
NO.
IC1
IC141
IC231
IC251
IC261
IC281
IC282
IC341
IC382
IC383
IC421
IC481
IC491
IC551
IC581
IC591
IC661
IC681
IC682
IC683
[MAIN UNIT]
ORDER
NO.
1140005990
1110002750
1110003201
1190000350
1110005340
1130007301
1130006220
1130007570
1110003800
1130007990
1110001811
1130007301
1110003800
1110005350
1110005770
1130011570
1140012420
1130007301
1130007301
1110002750
S.IC
S.IC
S.IC
S.IC
S.IC
S.IC
S.IC
S.IC
S.IC
S.IC
S.IC
S.IC
S.IC
S.IC
S.IC
S.IC
S.IC
S.IC
S.IC
S.IC
DESCRIPTION
H/V
M. LOCATION
MB15A02PFV1-G-BND-ER
TA75S01F (TE85R)
TA31136FNG (EL)
M62363FP-650C
NJM12902V-TE1
TC4W66FU F(TE12L)
TC4W53FU (TE12L)
BU4094BCFV-E2
NJM2904V-TE1
TC3W03FU (TE12L)
TA7368F G (ER)
TC4W66FU F (TE12L)
NJM2904V-TE1
NJM2870F05-TE1
S-80942CNMC-G9C-T2
BR24L32FV-WE2
µPD78F0338GC-9EB
TC4W66FU F(TE12L)
TC4W66FU F(TE12L)
TA75S01F (TE85R)
B 55.7/12.1
T 107.2/24.2
B 76.4/36.5
B 53.5/24.2
B 56.1/41.6
T
59/38.1
T 61.1/42.4
B
33/8.6
B
33.1/34
B
9.5/38.5
T 102.1/34.9
B
46/37.6
B
41/32.8
T 94.5/35.1
B
6.8/12.4
B
10.3/6.6
B
20/18.6
B
8.8/28.7
B 44.6/42.9
B 37.1/42.8
Q3
Q41
Q47
Q51
Q61
Q62
Q71
Q81
Q82
Q91
Q101
Q111
Q141
Q165
Q171
Q191
Q211
Q221
Q231
Q232
Q291
Q321
Q322
Q323
Q324
Q381
Q411
Q431
Q432
Q441
Q442
Q443
Q444
Q461
Q462
Q501
Q531
Q532
Q551
Q552
Q553
Q561
Q651
Q652
Q653
Q654
Q655
Q656
1560000540
1530002920
1590001190
1530002920
1530002380
1530002380
1530002380
1590001400
1590003290
1530003420
1560001240
1560001230
1590003230
1580000751
1560000840
1580000760
1530002600
1530002690
1590003230
1530003310
1590001650
1510000670
1510000670
1510000670
1590001770
1590003290
1530003091
1520000450
1590001190
1530002850
1560001330
1560001330
1590003290
1590003380
1590003380
1590003290
1590001770
1530002850
1520000450
1590001190
1590003290
1510000670
1590001770
1590000660
1590001770
1590003290
1590001540
1590003550
S.FET
S.TR
S.TR
S.TR
S.TR
S.TR
S.TR
S.TR
S.TR
S.TR
S.FET
S.FET
S.TR
S.FET
S.FET
S.FET
S.TR
S.TR
S.TR
S.TR
S.TR
S.TR
S.TR
S.TR
S.TR
S.TR
S.TR
S.TR
S.TR
S.TR
S.FET
S.FET
S.TR
S.TR
S.TR
S.TR
S.TR
S.TR
S.TR
S.TR
S.TR
S.TR
S.TR
S.TR
S.TR
S.TR
S.TR
S.TR
2SK880-Y (TE85R)
2SC4226-T1 R25
XP6501-(TX) AB
2SC4226-T1 R25
2SC4215-Y (TE85R)
2SC4215-Y (TE85R)
2SC4215-Y (TE85R)
XP1214 (TX)
UNR9213J-(TX)
2SC5110-O (TE85R)
RD01MUS1
RD07MVS1
UNR9113J-(TX)
3SK294 E (TE85L)
2SK1829 (TE85R)
3SK299-T1 U73
2SC4215-O (TE85R)
2SC4116-GR (TE85R)
UNR9113J-(TX)
2SC5107-O (TE85R)
XP4601 (TX)
2SA1588-GR (TE85R)
2SA1588-GR (TE85R)
2SA1588-GR (TE85R)
XP1213 (TX)
UNR9213J-(TX)
2SC4213-B F (TE85R)
2SB1132 T100 Q
XP6501-(TX) AB
2SC4116-BL (TE85R)
RSR025N03
RSR025N03
UNR9213J-(TX)
UNR9111J-(TX)
UNR9111J-(TX)
UNR9213J-(TX)
XP1213 (TX)
2SC4116-BL (TE85R)
2SB1132 T100 Q
XP6501-(TX) AB
UNR9213J-(TX)
2SA1588-GR (TE85R)
XP1213 (TX)
DTC144TU T106
XP1213 (TX)
UNR9213J-(TX)
UMD6N TR
XP4313 (TX)
D1
D31
D32
D33
D34
D35
D36
D37
D38
D39
D40
D41
D91
1790001250
1750000711
1750000711
1750000711
1750000711
1750000711
1750000711
1750000711
1750000711
1720000400
1790001620
1790000680
1790000620
S.DIO
S.VCP
S.VCP
S.VCP
S.VCP
S.VCP
S.VCP
S.VCP
S.VCP
S.VCP
S.DIO
S.DIO
S.DIO
MA2S111-(TX)
HVC350B-E
HVC350B-E
HVC350B-E
HVC350B-E
HVC350B-E
HVC350B-E
HVC350B-E
HVC350B-E
1SV245 (TPH3)
1SV308 (TPL3)
SB20-03P-TD
MA77 (TX)
B
B
B
B
B
B
B
T
T
T
T
T
T
B
B
B
T
B
T
T
T
T
T
T
B
B
T
T
T
T
T
T
T
B
B
B
B
B
B
B
B
T
B
B
B
B
T
B
REF
NO.
47.8/6
78.1/11.7
78.2/3.8
74.5/16.2
78.1/17.5
76.8/23.2
66.3/23.2
72.2/17.3
72.2/19.9
82.3/8.9
93.9/10.4
100.1/10
110/23
96.3/19
98.9/17.1
86.5/19.6
84.5/37.9
65.1/30.3
69.7/38.2
85.4/34
59.1/32.5
93.3/23.3
96.9/24.1
99.7/26.5
81.1/29.8
5.7/37.2
96.3/31.1
111.4/30.5
107.6/29.6
101.5/39.2
103.3/42.4
97.9/41.4
98.3/38.4
90.3/42.5
90/45.6
34.6/26.1
37.5/16.8
36.9/23
101.1/39.9
102.2/35.5
98.6/35
100.5/23.8
27.3/27.8
6.4/33.7
52/35.6
53.5/33.1
112.4/20.6
3.6/31.2
H/V
M. LOCATION
DESCRIPTION
D92
D121
D131
D132
D141
D151
D152
D153
D154
D155
D171
D181
D182
D231
D232
D601
D602
D603
1790000620
1790001670
1750000580
1790001210
1790001240
1750000580
1790001260
1790001620
1750000711
1750000711
1790001250
1750000711
1750000711
1750000520
1750000520
1790001260
1750000370
1790001250
S.DIO
S.DIO
S.DIO
S.DIO
S.DIO
S.DIO
S.DIO
S.DIO
S.VCP
S.VCP
S.DIO
S.VCP
S.VCP
S.DIO
S.DIO
S.DIO
S.DIO
S.DIO
FI211
2030000230
FI231
FI232
4580000160
2020001270
2020001410
S.MLH FL-355 (31.05 MHz)
[GEN], [EUR], [UK] B
S.FIL FL-377 MFT31P (31.05 MHZ) [USA] B
CER
CFWLB450KE2A-B0
CER
CFWLB450KGFA-B0
X1
X231
X381
X601
6050011940
6070000190
6050011560
6050011550
S.XTL
S.DCR
S.XTL
S.XTL
L31
L32
6200005540
6200007710
T
66.7/9.9
L165
L166
L181
L191
L203
L221
L222
6200008090
6200005540
6200007760
6200007730
6200007760
6200007770
6200006980
6200006980
6200006980
6200005720
6200007170
6200007170
6200006980
6200007690
6200009240
6200010640
6200009450
6200008280
6200003711
6200009800
6200008580
6200008280
6200005740
6200003960
6200007750
6200007750
6200001770
6200002150
6200003960
6200007750
6200007750
6200010960
6200009180
6200003960
6200004480
S.COL ELJNC R47K-F
S.COL LQW2BHN27NJ01L
[GEN], [EUR], [UK]
S.COL LQW2BHN68NJ01L
[USA]
S.COL ELJNC R47K-F
S.COL LQW2BHN82NJ01L
S.COL LQW2BHN39NJ01L
Except [USA]
S.COL LQW2BHN82NJ01L
S.COL LQW2BHNR10J01L
S.COL ELJRE R10G-F
S.COL ELJRE R10G-F
S.COL ELJRE R10G-F
S.COL ELJRE 33NG-F
S.COL MLF1608A 3R3K-T
S.COL MLF1608A 3R3K-T
S.COL ELJRE R10G-F
S.COL LQW2BHN18NJ01L
S.COL 0.20-1.0-7TL 31N
S.COL 0.26-1.0-3TL 8.5N
S.COL 0.20-1.0-6TL 25N
S.COL 0.30-1.7-7TL 50N
S.COL NLV25T 2R7J 2.7U
S.COL 0.26-1.1-7TR 30N
S.COL 0.30-1.4-6TL 32N
S.COL 0.30-1.7-7TL 50N
S.COL ELJRE 47NG-F
S.COL MLF1608A 1R0K-T
S.COL LQW2BHN56NJ01L
S.COL LQW2BHN56NJ01L
S.COL ELJNC 47NK-F [GEN], [EUR], [UK]
S.COL ELJNC 56NK-F
[USA]
S.COL MLF1608A 1R0K-T
S.COL LQW2BHN56NJ01L
S.COL LQW2BHN56NJ01L
S.COL C2520C-R47G-A (0.47U)
S.COL ELJRE R10J-F3
S.COL MLF1608A 1R0K-T
S.COL MLF1608D R82K-T
B
B
T
B
B
B
B
B
B
B
B
T
T
T
T
T
T
T
T
T
B
T
B
B
B
B
B
B
B
B
B
B
B
B
B
B
67.4/12.2
67.4/12.2
63.6/13.8
63.5/15.2
63.9/12.3
71.5/12.2
68.6/17.2
76.6/19.9
74.2/22.3
68.4/21.3
63.8/21.6
74.9/12.3
74.8/15.3
84.7/11.2
93.9/15.2
104.1/13.9
102.9/5.2
105.6/4.3
110.1/5.9
111.1/13
112.1/4.6
115.4/9.8
110/8.7
109.3/12
112.9/16.5
107.9/18
103.7/17.3
112.6/18.4
112.6/18.4
97.3/24.7
95.3/22.1
89.6/17.9
83.1/21.7
84.7/16
64.2/28.1
69.6/28.9
R1
R2
R4
R5
R6
R9
R15
R16
R17
R18
R19
R20
7030005100
7030007250
7510001660
7030003940
7030005110
7030005230
7030005050
7030005580
7030004980
7030005120
7030005000
7030005120
S.RES
S.RES
S.TMR
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
B
B
B
B
B
B
B
B
B
B
B
B
54/16.4
54.6/17.8
41.8/9.1
43.8/8
44.4/16.6
43.9/15.1
50/8.7
53.6/15.4
53.5/8.8
53.5/7.8
54.9/8.3
45.3/6.8
L33
L34
L35
L41
L51
L61
L62
L71
L72
L81
L82
L92
L102
L112
L121
L122
L123
L124
L131
L132
L151
L152
L153
L154
L155
L156
B 51.2/14.6
B
70.7/9.2
B
72/9.2
B
68.1/9.2
B
69.4/9.2
B
65.7/16
B 65.7/14.7
B 63.8/17.5
B 63.8/18.8
T 66.4/20.1
Except [USA] B
65.4/10
B 118.7/29.3
T 82.5/18.4
ORDER
NO.
MA77 (TX)
RB706F-40T106
1SV307 (TPH3)
1SS375-TL
MA2S728-(TX)
1SV307 (TPH3)
MA2S077-(TX)
1SV308 (TPL3)
HVC350BTRF-E
HVC350BTRF-E
MA2S111-(TX)
HVC350BTRF-E
HVC350BTRF-E
DAN222TL
DAN222TL
MA2S077-(TX)
DA221 TL
MA2S111-(TX)
T
T
T
T
T
B
B
B
B
B
B
B
B
T
T
T
B
B
CR-783 (15.3 MHz)
CDBCB450KCAY24-R0
CR-746 (4.000 MHz)
CR-747 (9.8304 MHz)
ERJ2GEJ 154 X (150 kΩ)
ERJ2GEJ 220 X (22 Ω)
NTCG16 4LH 473KT
ERJ3GEYF 104 V (100 kΩ)
ERJ2GEJ 224 X (220 kΩ)
ERJ2GEJ 334 X (330 kΩ)
ERJ2GEJ 103 X (10 kΩ)
ERJ2GEJ 560 X (56 Ω)
ERJ2GEJ 101 X (100 Ω)
ERJ2GEJ 102 X (1 kΩ)
ERJ2GEJ 471 X (470 Ω)
ERJ2GEJ 102 X (1 kΩ)
B
T
B
T
81.3/22
108.3/15.9
111.9/9.8
114.3/14
102.6/25.1
113.2/8.5
111.3/12.7
112.9/15.1
109.1/20.4
104.1/21.6
102/16.9
93.5/21.5
90.5/21.5
76.1/41.2
74.1/37.6
7.3/12.6
10/32.6
34.6/42.1
89.1/32.7
89.1/32.7
47.6/11.9
79.2/30.1
13.9/38.5
2.9/17.6
S.=Surface mount
M.=Mounted side (T: Mounted on the Top side, B: Mounted on the Bottom side)
6-1
[MAIN UNIT]
[MAIN UNIT]
REF
NO.
ORDER
NO.
DESCRIPTION
R21
R22
R31
R32
R33
R34
R35
R36
R37
R38
R39
R40
7030005050
7030005210
7030005530
7030005120
7030005120
7030005530
7030008300
7030005240
7030005090
7030005240
7030005090
7030005040
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
R41
R42
R43
R47
R51
R52
R53
R61
R62
R63
R64
R65
R71
R72
R81
R82
R83
R84
R91
R92
R93
R94
R95
R96
R97
R98
R101
R102
R103
R111
R112
R113
R114
R121
R122
R131
R132
R133
R141
R142
R143
R144
R145
R146
R147
R148
R149
R151
R152
7030006461
7030006571
7030009320
7030007290
7030006601
7030005331
7030009320
7030004980
7030005070
7030009320
7030005240
7030004980
7030005070
7030004990
7030007280
7030009280
7030005040
7030005040
7030005120
7030004980
7030005050
7030005030
7030005000
7030007300
7030005530
7030004980
7030005040
7030005060
7030005590
7030003200
7030005530
7030005040
7030005090
7030003580
7030000280
7030003670
7030007340
7030005050
7030005100
7030007350
7030007290
7030009140
7030008010
7030005050
7030005100
7030004980
7030005120
7030004980
7030005090
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
R153
R154
R155
R156
R165
7030005220
7030005110
7030005050
7030005110
7030005050
7030005090
7030008290
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
R166
7030005100
S.RES
R167
R171
R172
R173
R174
7030005700
7030005000
7030005050
7030005170
7030009290
7030007060
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
R175
R181
R182
R183
R184
R185
R191
R192
R193
R194
R201
R202
R203
7030005050
7030009270
7030005110
7030005050
7030005110
7030005050
7030005710
7030004980
7030007300
7030003520
7030005120
7030005050
7030005000
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
ERJ2GEJ 103 X (10 kΩ)
ERJ2GEJ 822 X (8.2 kΩ)
ERJ2GEJ 100 X (10 Ω)
ERJ2GEJ 102 X (1 kΩ)
ERJ2GEJ 102 X (1 kΩ)
ERJ2GEJ 100 X (10 Ω)
ERJ2GEJ 184 X (180 kΩ)
ERJ2GEJ 473 X (47 kΩ)
ERJ2GEJ 104 X (100 kΩ)
ERJ2GEJ 473 X (47 kΩ)
ERJ2GEJ 104 X (100 kΩ)
ERJ2GEJ 472 X (4.7 kΩ)
Except [USA]
ERA3YED 152V
ERA3YED 392V
ERJ2GEJ 4R7 X (4.7 Ω)
ERJ2GEJ 222 X (2.2 kΩ)
ERA3YED 272V
ERA3YED 562V
ERJ2GEJ 4R7 X (4.7 Ω)
ERJ2GEJ 101 X (100 Ω)
ERJ2GEJ 683 X (68 kΩ)
ERJ2GEJ 4R7 X (4.7 Ω)
ERJ2GEJ 473 X (47 kΩ)
ERJ2GEJ 101 X (100 Ω)
ERJ2GEJ 683 X (68 kΩ)
ERJ2GEJ 221 X (220 Ω)
ERJ2GEJ 331 X (330 Ω)
ERJ2GEJ 391 X (390 Ω)
ERJ2GEJ 472 X (4.7 kΩ)
ERJ2GEJ 472 X (4.7 kΩ)
ERJ2GEJ 102 X (1 kΩ)
ERJ2GEJ 101 X (100 Ω)
ERJ2GEJ 103 X (10 kΩ)
ERJ2GEJ 152 X (1.5 kΩ)
ERJ2GEJ 471 X (470 Ω)
ERJ2GEJ 332 X (3.3 kΩ)
ERJ2GEJ 100 X (10 Ω)
ERJ2GEJ 101 X (100 Ω)
ERJ2GEJ 472 X (4.7 kΩ)
ERJ2GEJ 333 X (33 kΩ)
ERJ2GEJ 680 X (68 Ω)
ERJ3GEYJ 100 V (10 Ω)
ERJ2GEJ 100 X (10 Ω)
ERJ2GEJ 472 X (4.7 kΩ)
ERJ2GEJ 104 X (100 kΩ)
ERJ3GEYJ 153 V (15 kΩ)
MCR10EZHJ 150 Ω (151)
ERJ3GEYJ 823 V (82 kΩ)
ERJ2GEJ 153 X (15 kΩ)
ERJ2GEJ 103 X (10 kΩ)
ERJ2GEJ 154 X (150 kΩ)
ERJ2GEJ 393 X (39 kΩ)
ERJ2GEJ 222 X (2.2 kΩ)
ERJ2GEJ 272 X (2.7 kΩ)
ERJ2GEJ 123 X (12 kΩ)
ERJ2GEJ 103 X (10 kΩ)
ERJ2GEJ 154 X (150 kΩ)
ERJ2GEJ 101 X (100 Ω)
ERJ2GEJ 102 X (1 kΩ)
ERJ2GEJ 101 X (100 Ω)
ERJ2GEJ 104 X (100 kΩ)
[GEN], [EUR], [UK]
ERJ2GEJ 223 X (22 kΩ)
[USA]
ERJ2GEJ 224 X (220 kΩ)
ERJ2GEJ 103 X (10 kΩ)
ERJ2GEJ 224 X (220 kΩ)
ERJ2GEJ 103 X (10 kΩ)
ERJ2GEJ 104 X (100 kΩ)
[USA]
ERJ2GEJ 183 X (18 kΩ)
[GEN], [EUR], [UK]
ERJ2GEJ 154 X (150 kΩ)
[GEN], [EUR], [UK]
ERJ2GEJ 274 X (270 kΩ)
[USA]
ERJ2GEJ 471 X (470 Ω)
ERJ2GEJ 103 X (10 kΩ)
ERJ2GEJ 474 X (470 kΩ)
ERJ2GEJ 562 X (5.6 kΩ)
ERJ2GEJ 684X (680 kΩ)
Except [USA]
ERJ2GEJ 103 X (10 kΩ)
ERJ2GEJ 821 X (820 Ω)
ERJ2GEJ 224 X (220 kΩ)
ERJ2GEJ 103 X (10 kΩ)
ERJ2GEJ 224 X (220 kΩ)
ERJ2GEJ 103 X (10 kΩ)
ERJ2GEJ 121 X (120 Ω)
ERJ2GEJ 101 X (100 Ω)
ERJ2GEJ 332 X (3.3 kΩ)
ERJ3GEYJ 472 V (4.7 kΩ)
ERJ2GEJ 102 X (1 kΩ)
ERJ2GEJ 103 X (10 kΩ)
ERJ2GEJ 471 X (470 Ω)
H/V
M. LOCATION
B
B
T
B
B
T
T
T
T
T
T
49.7/7.2
45.8/4.5
64.1/9.9
73.2/8.8
68.8/15.1
63.6/11.2
69.1/20.4
68.8/21.9
67.8/19.9
63.9/23
66.4/22.9
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
B
T
T
T
T
T
T
T
T
T
T
T
B
65.2/8.3
77/9.2
75.7/9
76.3/11.4
80.2/3.2
74.3/14.3
71.3/15.2
72.5/15.6
75.3/19.7
76.3/17.6
72/22.9
75/23.8
75/21.1
69.1/23.6
69.6/21.6
72.9/12.9
73.5/14.8
70/18.4
69.1/19.4
80.5/20.2
85/16.2
84.3/17.2
81.2/10.7
83.1/10.7
83.1/11.7
86.1/11.8
80.9/7
91.1/5.1
91.6/3.7
92/6.6
96.9/5.5
96.9/4.3
93/4.3
93/3.2
110.2/16.1
112.8/17.3
116.7/8.9
115.4/17.4
114.4/17.4
104.3/25.4
104.8/24
107.7/21.6
109.1/21.2
109.2/19.8
107.8/20.3
106.4/20.8
104.8/22.1
104.2/20.6
111.6/13.9
B
B
B
B
B
B
B
114.8/17.5
114.8/17.5
108.9/22.2
107.4/23.2
103.1/23.4
101.7/23.8
98.1/19.3
B
98.1/19.3
B
97/16.6
B
97/16.6
B 98.6/21.4
B 100.2/22.4
B 101.9/18.6
B 100.8/16.6
B
B
B
B
B
B
B
B
B
B
B
T
T
T
96/16.6
99.1/19.3
92.7/17.4
93.1/23.7
93.7/25.4
90.5/23.7
91.4/25.1
87.2/23.4
85.2/22
82.8/17.8
87.2/16.8
84.8/23.7
83.5/22.8
87.2/22
REF
NO.
ORDER
NO.
R204
R205
R206
R211
R213
7030010430
7030005000
7030005040
7030005120
7030005030
S.RES
S.RES
S.RES
S.RES
S.RES
R214
R215
R216
R221
R222
R223
R231
R232
R233
R234
R235
R236
R237
R238
R239
R240
R241
R242
R243
R244
R245
R246
R247
7030005120
7030005000
7030005310
7030005010
7030007060
7030007570
7030007270
7030007300
7030004970
7030007340
7030005220
7030005220
7030009320
7030008010
7030007340
7030005230
7030005600
7030007290
7030009280
7030009320
7030007290
7030005240
7030005240
7030007570
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
7030009140
S.RES
7030005000
7030005040
7030008010
7030005240
7030005210
7030010040
7030005050
7030009290
7030005050
7030005090
7030007340
7030005720
7030005100
7030005120
7030005120
7030008300
7030005050
7030006610
7030005090
7030005090
7030005090
7030005090
7030005070
7030005070
7030005070
7030005050
7030007340
7030005050
7030005040
7030005090
7030005070
7030007570
7030005050
7030005040
7030005050
7030005040
7030005050
7030005040
7030005050
7030005720
7030005090
7030008290
7030007300
7030005090
7030005160
7030005120
7030005050
7030010040
7030010040
7030010040
7030010040
7030010040
7030010040
7030005050
7030005050
7030005060
7030007310
7030007310
7030005530
7030005530
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
R251
R261
R262
R263
R264
R264
R265
R266
R267
R269
R270
R271
R272
R273
R274
R275
R276
R277
R281
R282
R283
R284
R291
R292
R293
R294
R296
R297
R298
R305
R306
R307
R321
R322
R323
R324
R325
R326
R381
R382
R383
R384
R385
R386
R387
R388
R389
R390
R391
R393
R394
R398
R399
R411
R412
R413
R414
R415
R421
R422
H/V
M. LOCATION
DESCRIPTION
ERJ2GEJ 120 X (12 Ω)
ERJ2GEJ 471 X (470 Ω)
ERJ2GEJ 472 X (4.7 kΩ)
ERJ2GEJ 102 X (1 kΩ)
ERJ2GEJ 152 X (1.5 kΩ)
[GEN], [EUR], [UK]
ERJ2GEJ 102 X (1 kΩ)
[USA]
ERJ2GEJ 471 X (470 Ω)
ERJ2GEJ 124 X (120 kΩ)
ERJ2GEJ 681 X (680 Ω)
ERJ2GEJ 684X (680 kΩ)
ERJ2GEJ 122 X (1.2 kΩ)
ERJ2GEJ 151 X (150 Ω)
ERJ2GEJ 332 X (3.3 kΩ)
ERJ2GEJ 470 X (47 Ω)
ERJ2GEJ 153 X (15 kΩ)
ERJ2GEJ 223 X (22 kΩ)
ERJ2GEJ 223 X (22 kΩ)
ERJ2GEJ 4R7 X (4.7 Ω)
ERJ2GEJ 123 X (12 kΩ)
ERJ2GEJ 153 X (15 kΩ)
ERJ2GEJ 334 X (330 kΩ)
ERJ2GEJ 273 X (27 kΩ)
ERJ2GEJ 222 X (2.2 kΩ)
ERJ2GE
ERJ2GEJ 4R7 X (4.7 Ω)
ERJ2GEJ 222 X (2.2 kΩ)
ERJ2GEJ 473 X (47 kΩ)
ERJ2GEJ 473 X (47 kΩ)
ERJ2GEJ 122 X (1.2 kΩ)
[USA], [GEN]
ERJ2GEJ 272 X (2.7 kΩ)
[EUR], [UK]
ERJ2GEJ 471 X (470 Ω)
ERJ2GEJ 472 X (4.7 kΩ)
ERJ2GEJ 123 X (12 kΩ)
ERJ2GEJ 473 X (47 kΩ)
ERJ2GEJ 822 X (8.2 kΩ)
ERJ2GE-JPW
ERJ2GEJ 103 X (10 kΩ)
ERJ2GEJ 562 X (5.6 kΩ)
ERJ2GEJ 103 X (10 kΩ)
ERJ2GEJ 104 X (100 kΩ)
ERJ2GEJ 153 X (15 kΩ)
ERJ2GEJ 563 X (56 kΩ)
ERJ2GEJ 154 X (150 kΩ)
ERJ2GEJ 102 X (1 kΩ)
ERJ2GEJ 102 X (1 kΩ)
ERJ2GEJ 184 X (180 kΩ)
ERJ2GEJ 103 X (10 kΩ)
ERJ2GEJ 394 X (390 kΩ)
ERJ2GEJ 104 X (100 kΩ)
ERJ2GEJ 104 X (100 kΩ)
ERJ2GEJ 104 X (100 kΩ)
ERJ2GEJ 104 X (100 kΩ)
ERJ2GEJ 683 X (68 kΩ)
ERJ2GEJ 683 X (68 kΩ)
ERJ2GEJ 683 X (68 kΩ)
ERJ2GEJ 103 X (10 kΩ)
ERJ2GEJ 153 X (15 kΩ)
ERJ2GEJ 103 X (10 kΩ)
ERJ2GEJ 472 X (4.7 kΩ)
ERJ2GEJ 104 X (100 kΩ)
ERJ2GEJ 683 X (68 kΩ)
ERJ2GEJ 122 X (1.2 kΩ)
ERJ2GEJ 103 X (10 kΩ)
ERJ2GEJ 472 X (4.7 kΩ)
ERJ2GEJ 103 X (10 kΩ)
ERJ2GEJ 472 X (4.7 kΩ)
ERJ2GEJ 103 X (10 kΩ)
ERJ2GEJ 472 X (4.7 kΩ)
ERJ2GEJ 103 X (10 kΩ)
ERJ2GEJ 563 X (56 kΩ)
ERJ2GEJ 104 X (100 kΩ)
ERJ2GEJ 183 X (18 kΩ)
ERJ2GEJ 332 X (3.3 kΩ)
ERJ2GEJ 104 X (100 kΩ)
ERJ2GEJ 105 X (1 MΩ)
ERJ2GEJ 102 X (1 kΩ)
ERJ2GEJ 103 X (10 kΩ)
ERJ2GE-JPW
[USA] only
ERJ2GE-JPW
ERJ2GE-JPW
ERJ2GE-JPW
ERJ2GE-JPW
ERJ2GE-JPW
ERJ2GEJ 103 X (10 kΩ)
ERJ2GEJ 103 X (10 kΩ)
ERJ2GEJ 333 X (33 kΩ)
ERJ2GEJ 155 X (1.5 MΩ)
ERJ2GEJ 155 X (1.5 MΩ)
ERJ2GEJ 100 X (10 Ω)
ERJ2GEJ 100 X (10 Ω)
T
T
B
B
85.9/20.8
86.4/19.5
85.9/16.5
85.9/25.2
T
T
T
T
T
B
B
B
T
T
T
T
T
T
T
T
B
B
B
B
T
T
T
T
88.3/38.5
88.3/38.5
85/35.9
86.3/38.5
86.6/36.8
63.3/29.8
62.3/29.8
81.3/38.2
80.6/35
83.1/35.9
76.1/43.4
71.9/39.2
72.5/36
73.9/39.3
71.9/38.2
78.5/37.6
80.7/34.3
78.2/33.2
82.9/36
73.1/33.2
71.9/37.2
82.6/34.6
85.1/32.2
86.8/31.1
B
81.9/32.3
B 81.9/32.3
B 57.8/18.3
B 62.8/36.5
B 61.2/39.2
B 60.8/37.8
B 60.9/40.2
B 60.9/40.2
B 58.6/37.8
B 59.8/38.3
B 63.5/41.1
B 57.6/37.8
B 60.9/43.3
B 63.4/43.1
B 60.7/44.7
B 59.7/45.3
B 62.1/44.5
T 56.6/41.3
T 56.9/44.9
T 55.5/43.5
T 62.2/38.8
T 57.8/35.7
T 58.9/44.3
T 59.7/35.7
T 61.5/34.1
T
62/32
T
61/32
T 63.4/29.6
T
60/34.3
T 56.1/31.7
T 56.6/29.4
T 60.5/30.5
T 59.2/30.2
T 57.1/32.2
T 93.5/21.4
T 91.5/23.2
T 95.4/22.2
T 95.1/23.7
T 97.8/26.5
T 96.8/26.5
B 35.4/30.3
B 33.2/29.6
B
35.6/32
B 30.6/34.1
B
33/38.4
B
36/35.7
B
9.8/41.7
B
7.2/40.2
B
7.3/36.6
B 62.9/10.4
T
83/14.8
T
82.5/6.4
T
89.2/4
B 60.6/41.5
T 58.9/42.5
T 98.7/31.4
T
94.3/32
T 94.3/30.1
T
99.2/29
T
97.2/29
T 107/33.5
B 104.4/38.7
S.=Surface mount
M.=Mounted side (T: Mounted on the Top side, B: Mounted on the Bottom side)
6-2
[MAIN UNIT]
[MAIN UNIT]
REF
NO.
ORDER
NO.
DESCRIPTION
R431
R432
R433
R434
R435
R441
R442
R443
R461
R462
R463
R467
R468
R471
R472
R473
R474
R475
R476
R477
R481
R482
R490
R491
R492
R493
R494
R495
R496
R497
R498
R501
R502
R503
R504
R511
R512
R513
R521
R531
R532
R533
R534
R535
R536
R537
R538
R539
R540
R551
R552
R553
R561
R562
R571
R572
R581
R583
R584
R591
R592
R601
R602
R603
R604
R605
R606
R611
R612
R631
R632
R633
R634
R635
R636
R637
R638
R639
R651
7030005600
7030005160
7030007290
7030007290
7030007300
7030005170
7030005170
7030005090
7030005060
7030005040
7030009290
7030008280
7030005090
7030007060
7030008290
7030005040
7030009290
7030010310
7030004740
7030004730
7030005090
7030005090
7030005720
7030007340
7030005110
7030008310
7030005250
7030005040
7030005110
7030008300
7030005090
7030005090
7030005060
7030005310
7030005050
7030005600
7030005100
7030008290
7030005010
7030005220
7030005220
7030005720
7030008300
7030005050
7030005240
7030005240
7030005120
7030005240
7030007340
7030005050
7030007290
7030005220
7030005050
7030005040
7030005930
7030008090
7030005050
7030005090
7030005090
7030005050
7030005050
7030005530
7030005160
7030008010
7030008010
7030008010
7030005120
7030005050
7030005040
7030005050
7030005090
7030005050
7030005050
7030005050
7030005050
7030005050
7030005050
7030005050
7030007280
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
R652
R653
R654
R656
R657
R658
R659
R662
7030005010
7030004990
7030005120
7030005010
7030005120
7030005010
7030005120
7030005010
7030007280
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
R663
R681
7030005010
7030004990
7030009150
S.RES
S.RES
S.RES
ERJ2GEJ 273 X (27 kΩ)
ERJ2GEJ 105 X (1 MΩ)
ERJ2GEJ 222 X (2.2 kΩ)
ERJ2GEJ 222 X (2.2 kΩ)
ERJ2GEJ 332 X (3.3 kΩ)
ERJ2GEJ 474 X (470 kΩ)
ERJ2GEJ 474 X (470 kΩ)
ERJ2GEJ 104 X (100 kΩ)
ERJ2GEJ 333 X (33 kΩ)
ERJ2GEJ 472 X (4.7 kΩ)
ERJ2GEJ 562 X (5.6 kΩ)
ERJ2GEJ 271 X (270 Ω)
ERJ2GEJ 104 X (100 kΩ)
ERJ2GEJ 684X (680 kΩ)
ERJ2GEJ 183 X (18 kΩ)
ERJ2GEJ 472 X (4.7 kΩ)
ERJ2GEJ 562 X (5.6 kΩ)
ERJ3GEYF 223 V (22 kΩ)
ERJ3GEYF 392 V (3.9 kΩ)
ERJ3GEYF 222 V (2.2 kΩ)
ERJ2GEJ 104 X (100 kΩ)
ERJ2GEJ 104 X (100 kΩ)
ERJ2GEJ 563 X (56 kΩ)
ERJ2GEJ 153 X (15 kΩ)
ERJ2GEJ 224 X (220 kΩ)
ERJ2GEJ 564 X (560 kΩ)
ERJ3GEYF 103 V (10 kΩ)
ERJ2GEJ 472 X (4.7 kΩ)
ERJ2GEJ 224 X (220 kΩ)
ERJ2GEJ 184 X (180 kΩ)
ERJ2GEJ 104 X (100 kΩ)
ERJ2GEJ 104 X (100 kΩ)
ERJ2GEJ 333 X (33 kΩ)
ERJ2GEJ 124 X (120 kΩ)
ERJ2GEJ 103 X (10 kΩ)
ERJ2GEJ 273 X (27 kΩ)
ERJ2GEJ 154 X (150 kΩ)
ERJ2GEJ 183 X (18 kΩ)
ERJ2GEJ 681 X (680 Ω)
ERJ2GEJ 223 X (22 kΩ)
ERJ2GEJ 223 X (22 kΩ)
ERJ2GEJ 563 X (56 kΩ)
ERJ2GEJ 184 X (180 kΩ)
ERJ2GEJ 103 X (10 kΩ)
ERJ2GEJ 473 X (47 kΩ)
ERJ2GEJ 473 X (47 kΩ)
ERJ2GEJ 102 X (1 kΩ)
ERJ2GEJ 473 X (47 kΩ)
ERJ2GEJ 153 X (15 kΩ)
ERJ2GEJ 103 X (10 kΩ)
ERJ2GEJ 222 X (2.2 kΩ)
ERJ2GEJ 223 X (22 kΩ)
ERJ2GEJ 103 X (10 kΩ)
ERJ2GEJ 472 X (4.7 kΩ)
ERJ3GEYF 334 V (330 kΩ)
ERJ3EKF 1503 V (150 kΩ)
ERJ2GEJ 103 X (10 kΩ)
ERJ2GEJ 104 X (100 kΩ)
ERJ2GEJ 104 X (100 kΩ)
ERJ2GEJ 103 X (10 kΩ)
ERJ2GEJ 103 X (10 kΩ)
ERJ2GEJ 100 X (10 Ω)
ERJ2GEJ 105 X (1 MΩ)
ERJ2GEJ 123 X (12 kΩ)
ERJ2GEJ 123 X (12 kΩ)
ERJ2GEJ 123 X (12 kΩ)
ERJ2GEJ 102 X (1 kΩ)
ERJ2GEJ 103 X (10 kΩ)
ERJ2GEJ 472 X (4.7 kΩ)
ERJ2GEJ 103 X (10 kΩ)
ERJ2GEJ 104 X (100 kΩ)
ERJ2GEJ 103 X (10 kΩ)
ERJ2GEJ 103 X (10 kΩ)
ERJ2GEJ 103 X (10 kΩ)
ERJ2GEJ 103 X (10 kΩ)
ERJ2GEJ 103 X (10 kΩ)
ERJ2GEJ 103 X (10 kΩ)
ERJ2GEJ 103 X (10 kΩ)
ERJ2GEJ 331 X (330 Ω)
[USA], [GEN]
ERJ2GEJ 681 X (680 Ω)
[Others]
ERJ2GEJ 221 X (220 Ω)
ERJ2GEJ 102 X (1 kΩ)
ERJ2GEJ 681 X (680 Ω)
ERJ2GEJ 102 X (1 kΩ)
ERJ2GEJ 681 X (680 Ω)
ERJ2GEJ 102 X (1 kΩ)
ERJ2GEJ 681 X (680 Ω)
ERJ2GEJ 331 X (330 Ω)
[USA], [GEN]
ERJ2GEJ 331 X (680 Ω)
[Others]
ERJ2GEJ 221 X (220 Ω)
ERJ2GEJ 824 X (820 kΩ)
H/V
M. LOCATION
T
T
T
T
T
T
T
T
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
T
T
B
B
B
T
T
B
B
T
T
T
T
T
T
T
T
B
B
B
B
B
B
B
B
B
106.1/27.6
107.6/27.1
109.4/33
105.8/29.6
108.1/32.1
100.7/41
96.7/38.3
99.5/39.9
94.3/48.5
47.8/44.6
50.3/42.8
97.3/40.8
90.5/40.4
51.7/43.1
56.2/38.3
50.7/44.2
50.2/40.3
58/35.5
57.2/33.5
60.7/35.5
47.3/35.4
42.3/39
39.3/37.5
41.1/37.4
37.4/25.8
39.1/36.2
44.4/33.6
38.5/31.3
38/29.3
39.4/24.7
39.4/25.7
43.5/31
40.7/27.3
38/27.2
44.6/29.7
33/23.6
36.6/28
32.6/25.6
45.1/31.1
34.6/18.9
33.4/15.5
34.1/16.5
34.1/17.5
35.5/17.3
36.3/18.9
36.3/20.8
35/23.4
39.3/21.3
39.3/22.3
99.9/36.5
100.4/35
100.5/33.5
100.3/21.8
98.7/23.4
105.2/30
103.1/27.3
9.2/12.3
6.4/34.4
6.9/33
10.7/12.1
8/9.6
6.6/17.4
6.1/18.9
7.8/15
6.5/14.4
7.3/10.3
6.8/8.8
54.8/42.5
54.3/44.8
25.5/7.6
23.9/5.2
15.9/6.7
23.9/7.1
17.1/5.8
14.7/5.3
14.3/6.6
13.7/9.6
12.7/9.8
T
T
T
T
T
T
T
T
T
63.1/4.3
63.1/4.3
62.1/3.8
15.8/38.2
14.8/38.2
16.3/11.8
15.3/11.8
16.2/22.7
15.2/22.7
T
T
T
B
68.9/4.3
68.9/4.3
70.3/3.3
12.7/27.2
REF
NO.
ORDER
NO.
DESCRIPTION
H/V
M. LOCATION
B
6.6/26.5
B
12/29.3
B 13.2/29.7
B
8.4/31.4
B
8.1/33.2
B
5.4/31.3
B
4.3/34.2
B
3.6/33.2
B 47.7/31.3
B 50.7/30.5
T
5.4/38.7
T 119.6/20.5
B 28.2/11.2
B 88.9/47.7
B 41.2/40.8
B 48.2/40.8
B 40.3/45.6
B 38.3/45.6
B 38.8/40.6
B 36.9/40.6
B 34.8/44.5
B 33.3/43.3
B
11/31.1
B 49.9/37.5
B
44.4/35
B 49.9/38.5
B
49.8/36
B 50.3/41.8
B 51.7/40.1
B 56.2/37.1
B 52.6/37.9
B
24.9/5.7
B 28.9/10.1
B 92.7/42.9
B
45/45.5
R682
R683
R684
R685
R686
R687
R688
R689
R690
R691
R692
R693
R694
R695
R696
R697
R698
R699
R700
R701
R702
R703
R704
R705
R706
R707
R708
R709
R710
R711
R712
R715
R717
R718
R720
7030005700
7030006610
7030003830
7030007340
7030005120
7030005120
7030005080
7030005240
7030010040
7030010040
7030010040
7030005120
7030005170
7030005090
7030005090
7030005090
7030007340
7030005230
7030007570
7030006610
7030005220
7030003830
7030005090
7030008290
7030008090
7030005210
7030008410
7030005040
7030005210
7030005090
7030005040
7030010040
7030010040
7030005120
7030010040
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
ERJ2GEJ 274 X (270 kΩ)
ERJ2GEJ 394 X (390 kΩ)
ERJ3GEYJ 185 V (1.8 MΩ)
ERJ2GEJ 153 X (15 kΩ)
ERJ2GEJ 102 X (1 kΩ)
ERJ2GEJ 102 X (1 kΩ)
ERJ2GEJ 823 X (82 kΩ)
ERJ2GEJ 473 X (47 kΩ)
ERJ2GE-JPW
ERJ2GE-JPW
ERJ2GE-JPW
ERJ2GEJ 102 X (1 kΩ)
ERJ2GEJ 474 X (470 kΩ)
ERJ2GEJ 104 X (100 kΩ)
ERJ2GEJ 104 X (100 kΩ)
ERJ2GEJ 104 X (100 kΩ)
ERJ2GEJ 153 X (15 kΩ)
ERJ2GEJ 334 X (330 kΩ)
ERJ2GEJ 122 X (1.2 kΩ)
ERJ2GEJ 394 X (390 kΩ)
ERJ2GEJ 223 X (22 kΩ)
ERJ3GEYJ 185 V (1.8 MΩ)
ERJ2GEJ 104 X (100 kΩ)
ERJ2GEJ 183 X (18 kΩ)
ERJ3EKF 1503 V (150 kΩ)
ERJ2GEJ 822 X (8.2 kΩ)
ERJ2GEJ 392 X (3.9 kΩ)
ERJ2GEJ 472 X (4.7 kΩ)
ERJ2GEJ 822 X (8.2 kΩ)
ERJ2GEJ 104 X (100 kΩ)
ERJ2GEJ 472 X (4.7 kΩ)
ERJ2GE-JPW
ERJ2GE-JPW
ERJ2GEJ 102 X (1 kΩ)
ERJ2GE-JPW
C1
C2
C3
C4
C5
C6
C10
C11
C12
C13
C14
C16
C17
C19
C20
C21
C31
C32
C33
C34
C35
C36
C37
C38
C39
C40
C41
C42
C43
C44
C45
C46
C47
C48
C51
C52
C52
C53
C54
C55
C56
C57
C61
C62
C63
C64
C65
C71
C72
C73
C74
C75
C81
C82
C83
C84
4030016930
4030016930
4030017460
4030017420
4030016930
4030018560
4030016930
4030017460
4030007010
4030017430
4030017460
4550006300
4550006160
4030017460
4030017460
4030017460
4030007040
4030007000
4030007070
4030017460
4030017730
4030018860
4030009540
4030018860
4030009920
4030009350
4030009550
4030007090
4030007020
4030017730
4030016790
4030009560
4550006700
4550006700
4030009560
4030009920
4030011770
4030007050
4030007040
4030017730
4030016790
4030009500
4030017460
4030006980
4030017460
4030016930
4030007040
4030009550
4030017460
4030006990
4030007100
4030007100
4030007020
4030007020
4030017420
4030016930
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.TAN
S.TAN
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.TAN
S.TAN
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
ECJ0EB1A104K
B
ECJ0EB1A104K
B
ECJ0EB1E102K
B
ECJ0EC1H470J
B
ECJ0EB1A104K
B
C2012 JB 1A 475K-T
B
ECJ0EB1A104K
B
ECJ0EB1E102K
B
C1608 CH 1H 100D-T
B
ECJ0EC1H101J
B
ECJ0EB1E102K
B
ECST1AY475R
B
ECST1CY155R
B
ECJ0EB1E102K
B
ECJ0EB1E102K
B
ECJ0EB1E102K
B
C1608 CH 1H 180J-T
B
C1608 CH 1H 090D-T
B
C1608 CH 1H 330J-T
B
ECJ0EB1E102K
T
ECJ0EB1E471K
T
ECJ0EB0J105K
T
C1608 CH 1H 1R5B-T
T
ECJ0EB0J105K
Except [USA] B
C1608 CH 1H 050B-T Except [USA] B
C1608 CH 1H 3R5B-T Except [USA] B
C1608 CH 1H 2R5B-T
B
C1608 CH 1H 470J-T
B
C1608 CH 1H 120J-T
B
ECJ0EB1E471K
B
ECJ0EB1C103K
B
C1608 CH 1H R75B-T
B
ECST1AY106R
B
ECST1AY106R
B
C1608 CH 1H R75B-T
B
C1608 CH 1H 050B-T
B
C1608 CH 1H 060B-T
B
C1608 CH 1H 220J-T
B
C1608 CH 1H 180J-T
B
ECJ0EB1E471K
B
ECJ0EB1C103K
B
C1608 CH 1H 0R5B-T
B
ECJ0EB1E102K
B
C1608 CH 1H 070D-T
B
ECJ0EB1E102K
B
ECJ0EB1A104K
B
C1608 CH 1H 180J-T
B
C1608 CH 1H 2R5B-T
B
ECJ0EB1E102K
B
C1608 CH 1H 080D-T
B
C1608 CH 1H 560J-T
B
C1608 CH 1H 560J-T
B
C1608 CH 1H 120J-T
T
C1608 CH 1H 120J-T
T
ECJ0EC1H470J
T
ECJ0EB1A104K
T
51/17.8
52.6/17.8
53.6/17.8
55.8/16.4
42.6/7.5
46.5/20
46.3/8.8
45.3/8.8
48.2/9.1
51.2/10.6
55.5/15.4
51.6/6.7
58/8.2
45.3/5.8
50/5.7
44.8/4.5
69.8/12
67.6/14.9
65.9/18
67.8/21.9
65.4/22.9
61.9/23
67.2/17.7
63.2/8.3
66.7/9.9
64.1/10
74.4/9
74.4/11
74.4/12.3
78.5/9.3
78.5/8.3
78.7/14.6
83.3/3
74.1/3.6
68.8/18.9
70/14.9
70/14.9
71.7/17.2
71.7/18.5
76.9/14.5
76.9/15.5
74.4/18.1
78.3/19.5
72.7/21
73/23.8
74/23.8
78.7/23
70.8/22.7
68.1/23.6
66.5/21.1
64.4/23.6
63.1/23.6
74.9/10.9
75.1/17.7
74.8/19.4
69.3/17.1
S.=Surface mount
M.=Mounted side (T: Mounted on the Top side, B: Mounted on the Bottom side)
6-3
[MAIN UNIT]
[MAIN UNIT]
REF
NO.
ORDER
NO.
DESCRIPTION
C91
C92
C96
C97
C98
C99
C100
C103
C104
C105
C106
C107
C111
C112
C113
C114
C115
C121
C122
C123
C124
C125
C126
C127
C128
C129
C131
C132
C133
C134
C135
C136
C137
C138
C141
C142
C143
C144
C145
C151
C152
C153
C154
C155
C156
C157
C158
C159
C160
C161
C162
C163
C164
C165
C166
C167
C168
4030007000
4030017460
4030017460
4030017420
4030017460
4030017460
4030017380
4030007030
4030016930
4030017460
4030017460
4030007050
4030007130
4030017460
4030016930
4030017420
4030017460
4030007100
4030007080
4030009650
4030006860
4030007030
4030007040
4030006860
4030017420
4030017460
4030006860
4030007050
4030011530
4030009650
4030006980
4030007000
4030017460
4030009500
4030016930
4030017460
4030016930
4030016790
4030017460
4030007000
4030007010
4030009530
4030017460
4030017460
4030011770
4030007060
4030017460
4030009550
4030009510
4030007100
4030017460
4030009910
4030006980
4030016790
4030017420
4030016790
4030006990
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
C171
C172
C173
C181
C182
C183
C184
C185
C186
C187
C188
C189
C191
C192
C193
C194
C195
C201
C202
C203
C210
C211
C213
4030011770
4030017480
4030017460
4030017420
4030017460
4030007120
4030017460
4030009550
4030009510
4030007070
4030017460
4030011770
4030009920
4030017460
4030017420
4030007100
4030016970
4030017460
4030017460
4030007060
4030006990
4550006300
4030017460
4030007000
4030011770
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.TAN
S.CER
S.CER
S.CER
C215
C216
C217
C221
C222
C223
C224
C225
C226
4030017460
4030016790
4030007130
4030007010
4030016790
4030007040
4030009520
4030007050
4030006980
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
C1608 CH 1H 090D-T
ECJ0EB1E102K
ECJ0EB1E102K
ECJ0EC1H470J
ECJ0EB1E102K
ECJ0EB1E102K
ECJ0EC1H050B
C1608 CH 1H 150J-T
ECJ0EB1A104K
ECJ0EB1E102K
ECJ0EB1E102K
C1608 CH 1H 220J-T
C1608 CH 1H 101J-T
ECJ0EB1E102K
ECJ0EB1A104K
ECJ0EC1H470J
ECJ0EB1E102K
C1608 CH 1H 560J-T
C1608 CH 1H 390J-T
C1608 CH 1H 240J-T
C1608 JB 1H 102K-T
C1608 CH 1H 150J-T
C1608 CH 1H 180J-T
C1608 JB 1H 102K-T
ECJ0EC1H470J
ECJ0EB1E102K
C1608 JB 1H 102K-T
C1608 CH 1H 220J-T
C1608 CH 1H 110J-T
C1608 CH 1H 240J-T
C1608 CH 1H 070D-T
C1608 CH 1H 090D-T
ECJ0EB1E102K
C1608 CH 1H 0R5B-T
ECJ0EB1A104K
ECJ0EB1E102K
ECJ0EB1A104K
ECJ0EB1C103K
ECJ0EB1E102K
C1608 CH 1H 090D-T
C1608 CH 1H 100D-T
C1608 CH 1H 030B-T
ECJ0EB1E102K
ECJ0EB1E102K
C1608 CH 1H 060B-T
C1608 CH 1H 270J-T
ECJ0EB1E102K
C1608 CH 1H 2R5B-T
C1608 CH 1H 010B-T
C1608 CH 1H 560J-T
ECJ0EB1E102K
C1608 CH 1H 040B-T
C1608 CH 1H 070D-T
ECJ0EB1C103K
ECJ0EC1H470J
ECJ0EB1C103K
C1608 CH 1H 080D-T
[GEN], [EUR], [UK]
C1608 CH 1H 060B-T
[USA]
C1608 JB 1A 474K-T
ECJ0EB1E102K
ECJ0EC1H470J
ECJ0EB1E102K
C1608 CH 1H 820J-T
ECJ0EB1E102K
C1608 CH 1H 2R5B-T
C1608 CH 1H 010B-T
C1608 CH 1H 330J-T
ECJ0EB1E102K
C1608 CH 1H 060B-T
C1608 CH 1H 050B-T
ECJ0EB1E102K
ECJ0EC1H470J
C1608 CH 1H 560J-T
ECJ0EB1C223K
ECJ0EB1E102K
ECJ0EB1E102K
C1608 CH 1H 270J-T
C1608 CH 1H 080D-T
ECST1AY475R
ECJ0EB1E102K
C1608 CH 1H 090D-T
[USA]
C1608 CH 1H 060B-T
[GEN], [EUR], [UK]
ECJ0EB1E102K
ECJ0EB1C103K
C1608 CH 1H 101J-T
C1608 CH 1H 100D-T
ECJ0EB1C103K
C1608 CH 1H 180J-T
C1608 CH 1H 020B-T
C1608 CH 1H 220J-T
C1608 CH 1H 070D-T
H/V
M. LOCATION
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
B
T
T
T
T
T
T
T
T
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
REF
NO.
C231
C232
C233
C234
C235
C236
C237
C238
C239
C240
C241
C242
C243
C244
C245
C246
C247
C251
C252
C253
C261
C262
C263
C265
C266
C267
C268
C269
C270
78.9/21.2
83/16.2
86.1/14.2
84.3/13
84.3/14
80.9/6
82.6/13
90/7
93.3/6.1
93.3/7.1
91.8/14.3
96.9/14.8
94.9/6.2
95.5/3.8
94.5/3.8
106.1/16.4
104.2/16.1
103.6/2.7
104.3/6.8
107.6/4.3
106.9/6.5
109.6/3
110.9/3
110.8/8.7
112.5/15.1
111.4/17.2
112.7/5.8
112.8/3
114.3/6.8
116.8/7.5
115.4/8.9
117.5/10.1
114.9/16.1
113/11.7
103.8/24
110.2/19.8
105.4/20.8
109.5/25.2
103.2/20.6
109/5.3
112.9/10.1
111.3/11.4
109.7/13.9
115.8/16.5
109.3/15.7
107.8/20.4
107/22.2
107.3/16.2
105.7/19.7
105.4/21.7
104.5/24
105.4/16.9
102.3/19.8
97.2/20.9
97.5/22.4
98.5/23.3
C272
C281
C282
C291
C292
C293
C294
C301
C302
C322
C323
C324
C325
C326
C341
C381
C382
C383
C384
C385
C386
C387
C388
C389
C391
C392
C393
C394
C395
C396
C397
C398
C411
C412
C413
C421
C422
C423
C424
C425
C426
C427
C431
C432
C441
C461
C462
C463
C464
C465
C466
C467
C472
C473
C481
C491
C492
C502
C503
C504
C511
C512
C521
B 110.6/15.7
B 110.6/15.7
B 100.4/19.7
B 94.7/16.1
B 94.7/17.1
B 93.9/19.8
B 92.1/21.5
B 92.1/23.7
B 92.4/16.2
B 92.6/18.6
B 89.2/21.5
B 89.5/23.7
B 89.6/16.2
B 89.7/19.6
B 87.2/21.4
B 87.2/22.4
B
83.2/19
B 82.3/15.5
B 82.8/16.8
T 82.5/23.8
T 85.3/22.5
T 84.7/19.2
T 87.2/29.5
B 88.1/27.6
B 92.8/34.6
B
T
T
T
B
B
B
B
B
B
92.8/34.6
82.7/38.2
87.3/38.5
80.3/38.5
60.1/28.1
61.3/29.8
67/30.4
67/28.1
68.3/30.4
70.9/28.9
ORDER
NO.
4030017460
4030007130
4030016930
4030016930
4030016930
4030016790
4030017720
4030017720
4550006300
4030017460
4030016930
4030017460
4030017460
4030017460
4030017460
4030017730
4030017460
4030016790
4030016790
4030016790
4030016780
4030017040
4030016950
4030017460
4030017700
4030017780
4030016950
4030016790
4030017920
4030018860
4030017480
4030016790
4030017460
4030016790
4030017790
4030017040
4030018080
4030016970
4030017760
4030016790
4030016790
4030016790
4550006710
4550006300
4030016790
4030018860
4030018860
4030018860
4030016930
4030016930
4030018860
4030018860
4030016790
4030016790
4030016930
4030017650
4030017650
4030017690
4030016930
4030018860
4030018860
4030017630
4030017480
4550006430
4030016930
4550006210
4030016930
4030017460
4550006700
4030017420
4030016950
4550007050
4030018860
4030016930
4030017420
4030017460
4030016930
4030016790
4030018860
4030018860
4030016930
4550006700
4550006700
4030016790
4030016790
4030016790
4030018860
4030017700
4030017780
4030017910
4030017770
4030016930
4030016930
H/V
M. LOCATION
DESCRIPTION
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.TAN
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.TAN
S.TAN
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.TAN
S.CER
S.TAN
S.CER
S.CER
S.TAN
S.CER
S.CER
S.TAN
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.TAN
S.TAN
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
ECJ0EB1E102K
C1608 CH 1H 101J-T
ECJ0EB1A104K
ECJ0EB1A104K
ECJ0EB1A104K
ECJ0EB1C103K
ECJ0EB1H331K
ECJ0EB1H331K
ECST1AY475R
ECJ0EB1E102K
ECJ0EB1A104K
ECJ0EB1E102K
ECJ0EB1E102K
ECJ0EB1E102K
ECJ0EB1E102K
ECJ0EB1E471K
ECJ0EB1E102K
ECJ0EB1C103K
ECJ0EB1C103K
ECJ0EB1C103K
ECJ0EB1C153K
ECJ0EB1A333K
ECJ0EB1A473K
ECJ0EB1E102K
ECJ0EC1H151J
ECJ0EB1E472K
ECJ0EB1A473K
ECJ0EB1C103K
ECJ0EB1A683K
[EUR], [UK]
ECJ0EB0J105K
[USA], [GEN]
C1608 JB 1A 474K-T
ECJ0EB1C103K
ECJ0EB1E102K
ECJ0EB1C103K
ECJ0EB1E682K
ECJ0EB1A333K
ECJ0EB1H182K
ECJ0EB1C223K
ECJ0EB1H222K
ECJ0EB1C103K
ECJ0EB1C103K
ECJ0EB1C103K
ECST1AX226R
ECST1AY475R
ECJ0EB1C103K
ECJ0EB0J105K
ECJ0EB0J105K
ECJ0EB0J105K
ECJ0EB1A104K
ECJ0EB1A104K
ECJ0EB0J105K
ECJ0EB0J105K
ECJ0EB1C103K
ECJ0EB1C103K
ECJ0EB1A104K
ECJ0EC1H270J
ECJ0EC1H270J
ECJ0EC1H121J
ECJ0EB1A104K
ECJ0EB0J105K
ECJ0EB0J105K
ECJ0EC1H120J
C1608 JB 1A 474K-T
ECST1VY474R
ECJ0EB1A104K
ECST1CX106R
ECJ0EB1A104K
ECJ0EB1E102K
ECST1AY106R
ECJ0EC1H470J
ECJ0EB1A473K
ECST1AD157R
ECJ0EB0J105K
ECJ0EB1A104K
ECJ0EC1H470J
ECJ0EB1E102K
ECJ0EB1A104K
ECJ0EB1C103K
ECJ0EB0J105K
ECJ0EB0J105K
ECJ0EB1A104K
ECST1AY106R
ECST1AY106R
ECJ0EB1C103K
ECJ0EB1C103K
ECJ0EB1C103K
ECJ0EB0J105K
ECJ0EC1H151J
ECJ0EB1E472K
ECJ0EB1H152K
ECJ0EB1E332K
ECJ0EB1A104K
ECJ0EB1A104K
B
T
T
T
T
T
B
B
B
B
B
B
B
B
T
T
B
B
B
B
B
B
B
B
B
B
B
T
B
B
T
T
B
T
T
T
T
T
T
T
T
T
B
T
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
T
T
T
B
T
T
T
T
B
B
T
T
T
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
82.8/38.2
75.7/34.7
73.3/35
68/38.2
74.9/31.8
77.5/36.7
82.2/34.7
82.2/33.7
84.5/36.8
81.5/36.7
81.5/35.7
72.6/31.3
74.6/31.3
75/33.2
80.6/36
86.9/32.2
71.9/36.7
56.8/18.3
57.3/29.6
58.8/18.5
62.8/38.4
61.8/37.8
62.5/40.5
54.2/38.3
58.4/44.9
62.4/43.1
64.9/44.3
56.9/43.1
66.2/43.4
66.2/43.4
62.7/35.6
57.9/44.3
112.4/31.3
63.4/30.7
63/33.3
62/30.1
63.4/31.8
57.1/28
56.1/28
92.1/20.9
94.9/20.9
95.4/26.9
102.9/31
112.8/25.1
36.3/11.5
30.2/40.7
27.7/32.2
26.6/31.2
36.6/33.4
29.5/30.5
30.6/36
35.7/38.7
30.6/32
36/36.7
7.9/41.6
17.1/41.9
17.1/34.3
10.4/34.9
7.9/42.6
28.7/33.3
31.1/39.7
7.3/38.4
99.1/30.2
92.7/30.8
100.6/31.4
106.5/39.7
103.8/29.3
104.8/29.3
109.1/35
104.9/31.4
104.4/40.6
108.3/30.8
108.6/27.1
107.1/32.1
104/40.2
94.3/47.5
48.3/42.8
49.2/43.8
44/45.5
43.2/40.7
89.5/40.4
96.8/42.4
59.7/32.2
52.6/44.4
46.8/39.8
39.1/29.3
37.4/24.8
40.7/28.3
39.1/27.1
36.6/27
33/24.6
33/27
47.2/30
S.=Surface mount
M.=Mounted side (T: Mounted on the Top side, B: Mounted on the Bottom side)
6-4
[VR UNIT]
[MAIN UNIT]
REF
NO.
ORDER
NO.
DESCRIPTION
C522
C531
C532
C533
C534
C535
C536
C552
C553
C554
C555
C556
C557
C561
C571
C581
C591
C601
C602
C603
C604
C605
C606
C611
C612
C641
C642
C643
C661
C662
C664
C665
C666
C667
C668
C669
C670
C671
C681
C682
C683
C684
C685
C686
C687
C688
C689
C690
C691
C692
C693
C695
C696
C697
C698
C699
C700
4030016970
4030016950
4030016940
4030016930
4030017740
4030016790
4030016950
4030017460
4550006820
4030016790
4030011810
4030017460
4550006710
4030016790
4030016790
4030017030
4030016790
4030017400
4030017590
4030017660
4030016790
4030017420
4030016790
4030017460
4030016970
4550006710
4030016790
4030016790
4030016950
4030017460
4030016950
4030016950
4030017040
4030016950
4030016950
4030016950
4030016950
4030016930
4030016930
4030017480
4030017480
4030017480
4030017480
4030017420
4030017420
4030016930
4030017460
4030016960
4030016960
4030017730
4030017460
4030018860
4030016930
4030016930
4030017460
4030017460
4030018860
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.TAN
S.CER
S.CER
S.CER
S.TAN
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.TAN
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
ECJ0EB1C223K
ECJ0EB1A473K
ECJ0EB1A393K
ECJ0EB1A104K
ECJ0EB1E821K
ECJ0EB1C103K
ECJ0EB1A473K
ECJ0EB1E102K
ECST1DX106R
ECJ0EB1C103K
C1608 JB 1A 224K-T
ECJ0EB1E102K
ECST1AX226R
ECJ0EB1C103K
ECJ0EB1C103K
ECJ0EB1A273K
ECJ0EB1C103K
ECJ0EC1H220J
ECJ0EC1H070C
ECJ0EC1H330J
ECJ0EB1C103K
ECJ0EC1H470J
ECJ0EB1C103K
ECJ0EB1E102K
ECJ0EB1C223K
ECST1AX226R
ECJ0EB1C103K
ECJ0EB1C103K
ECJ0EB1A473K
ECJ0EB1E102K
ECJ0EB1A473K
ECJ0EB1A473K
ECJ0EB1A333K
ECJ0EB1A473K
ECJ0EB1A473K
ECJ0EB1A473K
ECJ0EB1A473K
ECJ0EB1A104K
ECJ0EB1A104K
C1608 JB 1A 474K-T
C1608 JB 1A 474K-T
C1608 JB 1A 474K-T
C1608 JB 1A 474K-T
ECJ0EC1H470J
ECJ0EC1H470J
ECJ0EB1A104K
ECJ0EB1E102K
ECJ0EB1C183K
ECJ0EB1C183K
ECJ0EB1E471K
ECJ0EB1E102K
ECJ0EB0J105K
ECJ0EB1A104K
ECJ0EB1A104K
ECJ0EB1E102K
ECJ0EB1E102K
ECJ0EB0J105K
J352
J412
J414
6910016370
6510021900
6510024530
CNR
IMSA-9230B-1-06Z032-PT1
S.CNR BM02B-ASRS-TF
S.CNR 14FH-SM1-TB
DS653
DS654
DS656
DS657
DS658
DS659
DS681
5040002310
5040002310
5040002310
5040002310
5040002310
5040002310
5030002790
S.LED
S.LED
S.LED
S.LED
S.LED
S.LED
LCD
SML-311YTT86
SML-311YTT86
SML-311YTT86
SML-311YTT86
SML-311YTT86
SML-311YTT86
A0286 LCD39
MC461
7700002480
MIC
SKB-2746 LPC
S100
S101
S102
S103
S104
S105
S461
S641
2260002850
2260002850
2260002850
2260002850
2260002850
2260002850
2260002840
2260002800
S.SW
S.SW
S.SW
S.SW
S.SW
S.SW
SW
S.SW
EVQP2T02M
EVQP2T02M
EVQP2T02M
EVQP2T02M
EVQP2T02M
EVQP2T02M
SKHLLFA010
SW-167 (SKQTLAE010)
EP2
EP3
EP4
EP101
EP111
EP681
EP682
6910015370
6910015370
6910015370
6910013370
6910014690
8930064210
6910016340
S.BEA
S.BEA
S.BEA
S.BEA
S.BEA
LCT
E.OTH
ACZ1005Y-102-T
ACZ1005Y-102-T
ACZ1005Y-102-T
BLM18BB221SN1D
MPZ1608S221A-T
SRCN-2795-SP-N-W
CV1083 FX2795
REF
NO.
H/V
M. LOCATION
B
B
B
B
B
B
B
T
B
T
B
T
B
T
B
B
B
T
T
T
T
T
T
T
T
T
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
48.2/30
35.2/15.5
37.8/18.6
37.3/20.9
39.4/23.7
35/21.5
38.6/20
109.2/37.1
118.9/22.5
92.2/34.5
100.5/31.6
97.3/33.4
98.1/31
98.7/21.2
105.1/26.7
5.6/15.1
7.9/8.1
6.1/15.9
6.1/20.8
7.1/18.9
6.1/12.3
5.8/10.8
5.8/9.8
55.5/44.8
54.2/41.1
4/27.5
34.6/19.9
28.2/9.1
7.7/14.6
113.8/30.3
5.8/17.6
6.8/19.2
5.7/19.2
5.2/20.5
5.2/21.5
5.6/23
6.6/23
10/23.6
7.4/31.3
8.3/24.6
6.3/25.3
14.6/29.7
10.6/25.1
6.4/31.3
9.7/30.9
89.9/47.7
45.2/40.7
40/43
39.8/44.3
39.3/45.6
32.1/42.3
48.8/39.5
48.5/41.8
36/45.5
113.8/31.3
90.9/48
92.9/48
T
T
107.3/40.1
118.8/28.5
T
T
T
T
T
T
31.8/40.6
15.3/40.6
32.3/9.4
15.8/9.4
32.3/24.9
15.8/24.9
18.3/40.6
34.8/40.6
35.3/24.9
18.8/24.9
35.3/9.4
18.8/9.4
B
80.4/49
B
B
B
T
T
41.2/7.9
41.5/10.3
43.5/10.3
91.7/16.5
107/18
DESCRIPTION
R801
7210002530
VAR
F1
5210000900
S.FUS 0434003.NRP
M.
H/V
LOCATION
B
12.2/4.4
TP96N937N-15F-10KA-1540
[MIC UNIT]
REF
NO.
ORDER
NO.
DESCRIPTION
Q655
1590001770
S.TR
R713
R714
7030005010
7030005120
C700
C702
C703
XP1213 (TX)
H/V
M. LOCATION
B
3.6/2.1
S.RES ERJ2GEJ 681 X (680 Ω)
S.RES ERJ2GEJ 102 X (1 kΩ)
B
B
6.1/1.8
5.9/2.8
4030017420
4030017420
4030017620
S.CER ECJ0EC1H470J
S.CER ECJ0EC1H470J
S.CER ECJ0EC1H100C
B
B
B
11.4/5.1
3.8/5
4.5/7.8
J415
J416
6510022020
6510024650
S.CNR 14FLT-SM1-TB
CNR
246S-550-4P-134 (ORANGE)
B
6.6/13
DS655
5040003090
S.LED FRDG1211F-TR
B
10/1.8
W470
8900013540
CBL
OPC-1410 (N=14,L=50)
EP451
EP452
EP454
EP458
6910012350
6910012350
6910012350
6910012350
S.BEA
S.BEA
S.BEA
S.BEA
MMZ1608Y 102BT
MMZ1608Y 102BT
MMZ1608Y 102BT
MMZ1608Y 102BT
B
B
B
B
9.6/5.1
12.6/10.7
3.4/8.9
3.7/6.4
[CHASSIS UNIT]
REF
NO.
ORDER
NO.
DESCRIPTION
J41
6910016650
CNR
2795 ANT CONNECTOR
SP1
2510001092
SP
036D0801B <FG>
W3
8900010960
CBL
OPC-1129
H/V
M. LOCATION
• BC-158
[CHARGE UNIT]
REF
NO.
T
T
T
T
T
T
ORDER
NO.
ORDER
NO.
DESCRIPTION
R1
R2
R3
7070001130
7070001140
7010007100
RES
RES
RES
ERG2SJ 121 X (120 Ω)
ERG2SJ 151 X (150 Ω)
PSD1/4 V 102 (150 Ω)
J1
6510024940
CNR
HEC2305-016250
DS1
5040003020
LED
SEL2410G
H/V
M. LOCATION
S.=Surface mount
M.=Mounted side (T: Mounted on the Top side, B: Mounted on the Bottom side)
6-5
SECTION 7
MECHANICAL PARTS AND DISASSEMBLY
7-1 CABINET PARTS
[MAIN UNIT]
[MIC BOARD]
REF.
ORDER. NO.
DS681
5030002790
LCD A0286
DESCRIPTION
QTY.
1
EP681
8930064210
LCD contact SRCN-2795-SP-N-W
1
MP681
8930063850
2795 LCD holder
1
REF.
J416
ORDER. NO.
6510024650
DESCRIPTION
REF.
EP1
EP5
EP8
ORDER. NO.
DESCRIPTION
J41
6910016650
2600 ANT connector
1
EP9
SP1
2510001092
Speaker 036D0801B
1
MP1
MP2
8930068180 IC-GM1600 NECK STRAP
Optional product MB-103
W3
8900010960
Cable OPC-1129
1
MP1
8210021100
8210021170
8210020870
8930063640
8930063600
8210021090
8610011151
8930065070
8930063630
8930063840
8930063830
8930063820
8830001140
8930052280
8610012110
8830001480
8010019740
8930064200
8810009510
8830001600
8930065190
8930059800
8820001330
8810010150
8820001320
8930063690
8810009560
8810009560
8810010150
8510016610
8930064360
2795 Front panel (A)
2795 Front panel (C)
2795 SP panel
2795 SP rubber
2795 MIC cap
2795 rear panel
2497 BATT lock-1
2795 lock plate
2795 terminal holder
2795 A-terminal
2795 B-terminal
2795 C-terminal
VR nut (J)
O ring (AC)
Knob N-321 (A)
VR nut (O)
2795 chassis
2795 main seal
Screw B0 2X4 NI-ZU (BT)
Screw nut (L)
O ring (BB)
2600 pet sheet
Screw M3X3 BS NI
Screw B0 2X10 SUS ZK
2795 screw
O ring (BA)
Screw B0 2X6 ZK (BT)
Screw B0 2X6 ZK (BT)
Screw B0 2X10 SUS ZK
2795 shield plate
2795 antenna rubber
[CHASSIS PARTS]
MP8
MP10
MP18
MP20
MP21
MP22
MP23
MP24
MP25
MP26
MP31
MP32
MP33
MP35
MP41
MP46
MP47
MP51
MP52
MP66
MP69
MP70
MP71
MP73
MP74
MP75
MP76
MP77
MP80
ORDER. NO.
DESCRIPTION
Screw abbreviations
QTY.
[USA]
[Others]
1
[ACCESSORIES]
3310003330
Optional product
Optional product
Optional product
Optional product
REF.
QTY.
246S-550-4P-134 connector
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
9
1
1
1
2
2
4
4
3
1
2
1
1
FA-S61V
BP-224
BC-147A
BC-147E
BC-158
QTY.
[USA]
[GEN], [EUR]
Except [UK]
1
1
1
1
1
1
1
MP2
EP9
EP5
MP1
EP8*
B0, BT: Self-tapping
ZK: Black
SUS: Stainless
NI-ZU: Nickel-zinc
7-1
*Design is depend on versions.
EP1 (A)
Grease
MP73
NOTE 2
MP71 (C)
MP66 (C)
MP80 (C)
MP46 (C)
NOTE 2
J41 (C)
MP71 (C)
MP75 (C)
Unit: mm (inch)
MP69 (C)
MP74 (C)
NOTE 1 : Once the VR BOARD is removed from the front panel,
grease must be applied to the area described as above
when assembling.
Manufacture : Shin-Etsu Chemical
Type
: G-501
176 (6 15/16)
MP73
MP74 (C)
MP26 (C)
MP23 (C)
MP25 (C)
MP20 (C)
MP74 (C)
57.3 (2 1/4)
44 (1 23/32)
VR BOARD
MP24 (C)
W470 (MI)
145.3 (5 23/32)
159.6 (6 9/32)
294.9 (11 5/8)
MP32 (C)
MP18 (C)
NOTE 1
J416 (MI)
MP47 (C)
NOTE 2
MP70 (C)
MP33 (C)
MP31 (C)
65 (2 5/6)
MP51 (C)
MIC BOARD
MP41 (C)
W3 (C)
MP52 (C)
MP35 (C)
MP76 (C)
MP10 (C)
SP1 (C)
MP47 (C)
MP77 (C)
NOTE 2
MAIN UNIT
MP73 (C)
MP47 (C)
MP71 (C)
EP681 (M)
EP4 (A)
DS681 (M)
MP8 (C)
MP71 (C)
NOTE 2
MP681 (M)
NOTE 2 : When replacing the screws, 10 - 12 kg of torque
MUST be applied to ensure water resistance.
MP1 (C)
MP22 (C)
MP21 (C)
7-2
UNIT abbreviation (C): CHASSIS PARTS, (M): MAIN UNIT, (MI): MIC, (A): ACCESSORIES
SECTION 8
• TRANSISTORS AND FET’s
• BC-158 CHARGER PARTS LIST
2SA1588 GR
(Symbol: ZG)
MECHANICAL PARTS
2810 case
2523 cover
Screw B0 3 x 8 NI-ZU (BT)
Leg cushion (C)
QTY.
1
1
2
2
2SC4215 O
(Symbol: QO)
8930057120
8930057120
DESCRIPTION
2523 Terminal
2523 Terminal
MP1
1
1
2SK880 Y
(Symbol: XY)
CHARGE unit
B
C
C
C
E
E
E
S
3SK299 U73
(Symbol: U73)
3SK294
(Symbol: UV)
2SK1829
(Symbol: K1)
E
B
C
E
G1
S
G2
D
DTA144 TU
(Symbol: 06)
B
G
ORDER. NO.
8810001460
B
B
C
E
2SC5110 O
(Symbol: MGO)
QTY.
[ACCESSORIES]
REF.
B
E
2SC5107 O
(Symbol: MFO)
2SC4226 R25
(Symbol: R25)
2SC4215 Y
(Symbol: QY)
C
ORDER. NO.
E
E
E
B
REF.
C
C
C
E
[CHARGE UNIT]
MP1
MP2
B
B
B
C
E
8
5
8510016540
8110007680
8810008660
8930047830
DESCRIPTION
C
-1
ORDER. NO.
2SC4213 B
(Symbol: AB)
2SC4116 GR
(Symbol: LG)
2SC4116 BL
(Symbol: LL)
B
B
C
B
MP1
MP2
MP3
MP4
2SB1132 Q
(Symbol: BAQ)
MP1(C)
[CHASSIS UNIT]
REF.
SEMICONDUCTOR INFORMATION
DESCRIPTION
Screw A0 3.5 x 20 SUS
D
MP1 (CH)
QTY.
2
MP2 (CH)
RD07MVS1
(Symbol: RD07MVS1)
RD01MUS1
(Symbol: K2)
MP1
C
G
MP2 (C)
G
S
D
D
S
D
UNR9111J
(Symbol: 6A)
UMD6
(Symbol: D6)
RSR025N03
(Symbol: QY)
G
S
E
E1
C1
B1
B2
C2
E2
B
C
E
S
UNR9113J
(Symbol: 6C)
Screw abbreviations
UNR9213J
(Symbol: 8C)
XP1213
(Symbol: 9L)
XP4313
(Symbol: 8S)
XP4601
(Symbol: 5C)
MP4 (C)
A0, B0, BT: Self-tapping
NI-ZU: Nickel-zinc
SUS: Stainless
E
E
C1
B1
E1
B2
• CIRCUIT DIAGRAM
C1
E1
B2
C2
E1
C1
E1
C1
B1
B2
B1
B2
C2
E2
C2
E2
XP6501 AB
(Symbol: 5N)
XP1214
(Symbol: 9H)
NOTE: (C) : CHASSIS
(CH) : CHARGE UNIT
C
C
MP3 (C)
B1
B
B
MP4 (C)
C2
E1
C1
E2
B1
B2
C2
• DIODES
1
HEC2305-01-250
R1 120
H
CC
1SS375
(Symbol: FH)
1SV245
(Symbol: T3)
1SV307
(Symbol: TX)
1SV308
(Symbol: TX)
DA221
(Symbol: K)
MP1
GN
A1
GN
A1
C
R2 150
C
A2
A2
DAN222
(Symbol: N)
HVC350B
(Symbol: B0)
MA2S077
(Symbol: S)
RB706F-40
(Symbol: 3J)
SB20-03P
(Symbol: SC)
MA2S111
(Symbol: A)
S1 SEL2410G
R3 1 k
A1
C
A2
GN
MP2
MA77
(Symbol: 4B)
C
7-3
A
8-1
MA2S728
(Symbol: B)
SECTION 9
BOARD LAYOUTS
9-1 MAIN UNIT
•
TOP VIEW
Horizontal
5
10
15
20
25
30
35
40
45
50
55
60
65
70
75
80
85
90
95
100
105
110
115
120
50
0
R233
Q441
IC421
R433
J414
C326
C144
R693
D132
L132
C138
L124
L123
C131
C132
C123
L121
R112
C124
R132
R133
C129
R121
C114
Q111
R111
R122
C142
R145
R147
C143
C431
R432
IC141
C141
R142
R149
C145
R143
D141
Q323
R562
C122
L122
C113
D131
C127
C125
C126
R114
C112
R102
R113
C137
C128
C121
C105
C104
C111
C103
R394
R662
R651
R435
C432
R434
C422
C423
Q411
R326
R325
C561
C322
EP101
C106
Q101
5
R652
D121
L112
R101
R663
Q655
C107
C97
R103
R98
R146
Q141
R144
C136
R443
IC551
R412
R324
R322
R203
C96
R391
R95
R148
R561
C115
L102
Q91
L31
R321
R205
R92
L92
R81
C100
R96
R94
R393
DS658
L82
R82
L33
R34
R656
R657
DS657
C81
Q561
R97
C84
R603
D601
R605
R31
S104
L81
Q321
EP111
C98
C99
9-1
Q432
R141
R323
R93
C92
R606
J412
Q443
C82
C203
D91
C83
Q81
C202
R204
D92
R83
S105
Q431
R414
Q322
C323
C201
R202
R201
R91
C91
Q82
C34
R37
C603
D39
C602
R602
R35
R84
C37
C601
X601
C604
C606
R36
C35
R38
C36
R39
DS658
DS659
R658
R659
25
20
15
R415
S102
R604
10
C210
C425
C413
C411
R431
R601
C605
R421
R411
J414
to the MIC board J415
C424
C301
C302
X231
R294
C324
S103
–
C556
C246
R245
R413
C293
R306
30
C641
0
Vertical
R298
C291
Q444
R442
R213
Q232
R244
C235
R293
C294
C216
R214
C554
C232
R232
R231
R246
R305
C441
C552
C412
C245
R291
Q211
R441
4 GND
GND
AFOUT
1 SPGO
+
R216
R235
C233
R215
C215
R238
C236
D232
Q231
C272
C217
C292
R292
Q291
R307
R297
C234
R281
IC281
R284
R583
R237
R243
R296
R584
R236
R234
to the SP1
Q442
C133
R283
R399
R276
R269
D231
R282
35
SP1
(CHASSIS unit) J412
IC282
R275
C612
S101
DS653
S100
R653
R654
R692
40
DS654
R611
C281
C611
R277
R612
45
MC461
C134
1 RLED
TLED
EXMIC
EXDET
GND
GND
GND
SPG
SPG
AFOUT
AFOUT
S5V
GND
14 GND
• BOTTOM VIEW
50
C392
R388
C398
X381
R389
C393
C394
C386
C686
IC681
C670
C535
R535
IC661
C664
R534
R533
C581
R532
IC581
R581
R591
15
R638
R637
R635
R715
CP1
R633
R631
IC341
EP2
10
R592
C591
C643
R634
R4
R639
R694
R717
C19
R22
Q3
20
C666
C665
R531
R20
C20
l
C668
R632
R21
25
IC591
R636
5
C48
0
115
110
105
100
95
90
85
80
75
70
65
60
55
50
45
40
35
30
25
Horizontal
9-2
20
15
10
5
0
120
V ti
C682
C671
C683
C667
C341
R18
R687
R686
R685
D602
R704
R683
C684
C681
R384
C388
C512
R538
Q532
C533
R684
R496
R503
30
R682
C685
EP3
C5
R5
C11
C10
R15
C12
Q656
C642
Q531
R6
C687
R689
C669
R703
C693
D603
IC683
C384
C491
C503
C536
C1
C3
C13
EP4
C21
Q47
R47
C47
35
Q652
C661
X1
C16
C17
Q381
R681
R513
R511
C531
R17
40
R9
IC1
MP41
C38
C2
R2
R16
C14
D1
L34
D40
C39
R390
C32
R40
C40
L35
L32
D33
C52
C31
D34
R33
R52
L41
R53
D32
D36
Q651
C511
R537
IC251
C251
R251
C253
C33
Q51
R32
C43
C42
R383
R495
R501
R504
C221
C74
C75
C72
R71
R72
L71
C71
C534
R1
C4
Q501
C492
R497
C532
D37
D35
C385
C504
R540
D38
C382
C383
R492
R539
R19
C45
L51
R51
R41
R42
C44
C53
D31
C55
R43
C46
C194
C56
C57
C51
C396
R512
R502
IC383
R688
R382
C502
L72
C73
IC382
R381
C6
C54
C697
R702
C692
R699
R698
R270
C464
C690
R386
R536
R708
C522
R521
C391
C389
R493
R712
IC381
R490
R491
IC491
R61
L61
Q61
C195
MP111
C63
C62
C41
R193
R62
C61
C193
R63
C64
R64
C65
L62
R65
Q71
R385
R706
Q654
C472
C397
C387
R494
C252
C395
R387
C381
R701
R700
R482
R474
R710
IC682
R462
IC481
IC261
R269
Q653
R481
R690
C222
R221
L221
C224
R705
C521
R272
R266
C262
R263
R265
R475
R696
C465
45
C481
C695
R691
Q221
R222
C225
C223
C226
L222
R473
R471
C267
R398
R271
R267
C261
R261
C247
IC231
R477
B6190B
C691
C689
R707
R716
R711
R247
L191
R192
Q62
Q41
L151
C265
R211
C188
Q191
R206
C186
C187
R184
D182
C182
C184
L181
C191
L203
C172
R181
C192
R194
R174
C173
C263
FI232
C231
R241
C239
FI211
R183
C183
R182
L166
D181
C189
C185
R273
R695
Q462
C213
C557
C167
C166
R167
R165
Q171
R173
R166
R155
R171
C171
R175
C161
D155
D171
Q165
R191
C151
L131
R185
C181
R472
C462
C696
R697
R262
R476
C242
R463
R709
R264
R242
C244
C463
R498
L152
D152
C153
D151
R240
C154
R151
C152
C159
L155
L153
C163
L154
C165
C473
R270
C238
Q324
L165
C571
D154
L156
C168
C156
R152
C155
R156
C164
C160
C241
C211
R172
D153
R131
C135
C158
C157
C553
R154
C240
C243
R572
C162
R153
C555
C325
R571
C427
D41
R223
C237
R553
C662
J41
(CHASSIS unit)
R552
Q552
Q553
J352
R551
C282
R698
R468
R422
Q551
C266
R239
C426
C421
R467
C270
C466
R718
C467
R274
C268
FI231
Q461
S461
6 GND
VOLO
VOLIN
NC
VCC
1 VCC
C688
C700
C461
J352
C699
S641
R461
9-2 VR BOARD
•
TOP VIEW
Horizontal
0
5
10
15
R801
Vertical
0
5
10
9-3 MIC BOARD
•
TOP VIEW
Horizontal
0
5
10
15
0
Vertical
5
10
J416
15
9-4 BC-158
TOP VIEW
Horizonal
65
60
55
50
45
40
35
30
25
20
15
10
5
0
0
5
R3
DS1
R2
10
MP1
MP2
R1
B5787B
J1
15
20
HV
GND
GND
J1
to the AC adapter AC-147A/E
9-3
Vertical
•
•
BOTTOM VIEW
Horizontal
15
10
5
0
Vertical
F1
B6191C
0
5
10
•
BOTTOM VIEW
Horizontal
10
5
0
0
J415
to the MAIN unit J414
8
EP452
J415
SPG
SPG
AFOUT
AFOUT
GND
GND
GND
EXDET
EXTMIC
TLED
RLED
10
C702
C700
EP458
EP451
Vertical
C703
EP454
5
R714
R713
Q655
B6192B
DS655
15
7
1
BOTTOM VIEW
Horizonal
0
5
10
15
20
25
03
0
5
Vertical
•
14
GND
GND
15
10
15
20
9-4
35
40
45
50
55
60
65
SECTION 10
BLOCK DIAGRAM
ANTENNA
V5V
RIPPLE
FIL
VCO
Q47: XP6501
Q41: 2SC4226
D31-34: HVC350B
LOINV
Q3: 2SK880
15.3 MHz
FM
MOD
LOOP
FIL
D35-38:
HVC350B
X231:
CDBC450CX24
30.6 MHz
DET
D231:
DAN222
W/N
SW
RLED
BPF
D182:
HVC350B
Q191:
3SK299
BPF
31.05 MHz
PWR
AMP
LPF
RF
AMP
BPF
D154:
HVC350B
BPF
BPF
W/N
SW
T3CON
T2CON
BTYPE
W/NS
EXDET
LDTFS
WDECV
BEEP
ISPMS
T1CON
FI231:
CFWM450E
CERAMIC
BPF
RSSIV
AFVS
NOISV
AFMS
TEMPV
MICMS
BATTV
ETXDO
PTTIN
ERXDI
EXPTT
SQLT
MOCON
DEENPHA
D/A
Q652: DTC144TU
D602: DA221
IC251:
M12363FD-650C
BEEPO
D/A control BUS
BUFF
EXTMIC
Q322: 2SA1588
MODIN
ERXDI
SPG
EXDET
R5V
R5V
REG
R5VS
ETXDO
Q501:
UNR9213J
CTFIS
IC282:
TC4W53FU
IC261C:
NJM12902V
CHASSIS
WDECV
ANALOG
SW
LPF
IC281A:
TC4W66FU
X601:
CR-747
Q323: 2SA1588
T5V
W/N
SW
T5V
REG
D601:
MA2S077
SHIFT
SW
T5VS
AF
MUTE
LCD
CSIFT
9.8304 MHz
IC661:
UPC78F0338GC
Q321: 2SA1588
IC261D:
NJM12902V
ISPMS
AF
MUTE
Q441: 2SC4116
Q442, Q443: RSR025N03
Q444: UNR9213J
MIC
INT
MIC SW
IC491A:
NJM2904V
DETMS
LIMIT
AMP
LPF
Q462:
UNR9111J
V5V
EXT
MIC SW
PTTIN
V5V
REG
IC581: S-80942CNMC
V5VS
RESET
LPF
Q561: 2SA1588
BEEPO
EXPTT
IC261A:
NJM12902V
IC683
TC75S01F
VOX
AMP
VOX
S5V
REG
S5VS
Q551: 2SB1132
Q552: XP6501
Q553: UNR9213J
VOXT
IC682A:
TC4W66FU
AF
MUTE
AF
MUTE
PTTM
PREENPHA
MIC
AMP
BACK
LIGHT
IC551:
NJM2870
Q651: XP1213
CPU
5V
DRIVER
IC591: BR24L32FV-W
CPU5V
IC261B:
NJM12902V
CPU
VCC
M5V
IC682B:
TC4W66FU
EP682:
CV1083
DS653, DS654, DS656,
DS657, DS658, DS659:
SML-311YT
IC491B:
NJM2904V
S5V
Q461: UNR9111J
PTT
D155:
HVC350B
Q165:
3SK294
T1CON
T2CON
T3CON
T4CON
EXDET
INTSP
D181:
HVC350B
CERAMIC
BPF
S5V
AFOUT
FI211: FL-377
FI232:
CFWM450G
AFVS
IC421
TA7368F
EXT JACK
ANT
SW
MUTE
SW
LOINV
TLED
DRIVER
TXMS
T4CON
VCC
PWR
CTRL
TDETV
D131, D151: 1SV307
D152: MA2S077
IC231:
TA31136FN
D232:
DAN222
TX/RX
LIGHT
PWR
DET
APC
CTRL
NOISV
W/NS
Q655:
XP1213
Q211:
2SC4215
IF
AMP
FM IF IC
SQCON
VCC
DS655:
FRDG1211F
T1CON
ATT
BUFF
MAIN UNIT
RSSIV
VCC
Q431: 2SB1132
Q432: XP6501
VCO
SW
D132:
1SS375
PLL DATA BUS
Q232: 2SC5107
Q231: UNR9213J
Q324: XP1213
SQLT
W/N
SW
W/NS
AFMS
MIC
IC141:
TA75S01F
LPF
AF
MUTE
BPF
PWR
AMP
Q141:
UNR9113J
Q411:
2SC4213
POWER SW
PRE
DRIVE
Q71: 2SC4215
PLL
IC
X2
VR BOARD
BUFF
Q111:
RD07MVS1
IC1:
MB15A02PFV
Q221:
2SC4116
BATT
Q101:
RD01MUS1
Q81: XP1214
Q82: UNR9113J
X1: CR-783
VOLIN
VOLO
GND
TX/RX
SW
BUFF
Q51:
2SC4226
DTCON
REF
Q62: 2SC4215
Q91:
2SC5110
VCOS
D39:
1SV245
FRCON
Q61: 2SC4215
BUFF
BUFF
146-174 MHz
D91, D92: MA77
EEPROM
KEY
M5VS
LPF
Q653: XP1213
Q654: UNR9213J
GAIN
CTRL
M5V
REG
NOTES :
IC481A:
TC4W66FU
Contorol line
AF
MUTE
Common line
ATIS
TX line
MIC 1, 2, 3
RX line
MICMS
VOXM
DATA lime
10 - 1
C691
0.018
11 - 1
R716
R711
100 k
IC261
NJM12902V
3
AG3V
AG3V
IC481
TC4W66FU
1
2
3
4
MOD
8
7
6
5
R491
15 k
1
2
3
4
UNLKI
EXOEO
VSSTBO
EXSTBO
R493
560 k
R495
4.7 k
DASTBO
PLSTBO
SDATAO
SCLKO
R717
ERJ2GE-JPW
S103
EVQP2T02M
R631 10 k
R634 10 k
R635 10 k
R636 10 k
R633 10 k
R637 10 k
R638 10 k
R639 10 k
8
7
6
5
AFOUT
S5V
AG3V
ISPMS
CPU5V
ATIS
C643
0.01
CPU5V
SQL
PTTIN
EXPTT
BTYPE
PTTM
MIC1
MIC2
MIC3
SQL
UP
DOWN
CH/WX
16/9
SCAN
H/L
TDEC
CP641 VOXM
UNLK
EXOE
S105
EVQP2T02M
W/NS
VSSTB
EXSTB
91
92
93
94
95
96
97
98
99
100
101
102
103
104
105
106
107
108
109
110
111
112
113
114
115
116
117
118
119
120
BEEP
VSS0
VDD0
P60
P61
P62
P63
P64
P65
P66
P67
P40
P41
P42
P43
P44
P45
P46
P47
P50
P51
P52
P53
P54
P55
P56
P57
P70/TO4
P71/TI4
P72/TO52
P73/TI52
IC661
PD78F0338GC-9EB (FX-2795A)
DASTB
PLSTB
SDATA
SCLK
IC491
NJM2904V
S9
S8
S7
S6
S5
S4
S3
S2
S1
S0
SCOM0
COM3
COM2
COM1
COM0
VLC2
VLC1
VLC0
VLCDC
CAPL
CAPH
AVREF1
P120/AO0
AVSS0
ANI9
ANI8
P17/ANI7
P16/ANI6
P15/ANI5
P14/ANI4
EXDET
OSC1
X601
CR-747
R601 10
R602
1M
BATTV
VOXT
C603
33 P
C670 0.047
C669 0.047
C668 0.047
R684
1.8 M
R681
820 k
C605
47 P
C604
0.01
R604
12 k
C681 0.1
R683 390 k
SEG23
SEG22
SEG21
SEG20
SEG19
SEG18
SEG17
SEG16
SEG15
SEG14
SEG13
SEG12
SEG11
SEG10
R421
10
SEG0
SEG1
SEG2
SEG3
SEG4
SEG5
SEG6
SEG7
SEG8
SEG9
SEG10
SEG11
SEG12
SEG13
SEG14
SEG15
SEG16
SEG17
SEG18
SEG19
SEG20
SEG21
SEG22
SEG23
COM0
COM1
COM2
C427 150
C425 47 P
C426 R422
0.047 10
C424
10
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
R413 33 k
C421 10
SEG0
SEG1
SEG2
SEG3
SEG4
SEG5
SEG6
SEG7
SEG8
SEG9
SEG10
SEG11
SEG12
SEG13
SEG14
SEG15
SEG16
SEG17
SEG18
SEG19
SEG20
SEG21
SEG22
SEG23
COM0
COM1
COM2
R694
470 k
C423 0.001
C422 0.1
BTYPE
AF7V
C671
0.1
C683 0.47
60 SEG9
59 SEG8
58 SEG7
1
8
57 SEG6
2
7
56 SEG5
3
6
55 SEG4
4
5
54 SEG3
53 SEG2
52 SEG1
IC681
51 SEG0
TC4W66FU
50
49
48 COM2
47 COM1
46 COM0
45
44
43
42
41 C685 0.47
40
39
CPU5V
38
ATIS
37
36
CDECV
35
TEMPV
34
LOINV
33
RSSIV
32
NOISV
31
TDETV
C682
0.47
C684 0.47
C642 0.01
T5VS
R5VS
V5VS
S5VS
M5VS
AFVS
AFMS
W/NS
LDTFS
ISPMS
MICMS
STXMS
LEDS2
LEDS1
CPU5V
C667 0.047
BEEPO
C665 0.047
IC591
BR24L32FV-W
90
89
88
87
86
85
84
83
82
81
80
79
78
77
76
75
74
73
72
71
70
69
68
67
66
65
64
63
62
61
C641
22
R591 10 k
R592 10 k
8
VCC 7
WP 6
SCL 5
SDA
C666 0.033
1
2 A0
3 A1
4 A2
VSS
P87/S39
P86/S38
P85/S37
P84/S26
P83/S35
P82/S34
P81/S33
P80/S32
P97/S31
P96/S30
P95/S29
P94/S28
P93/S27
P92/S26
P91/S25
P90/S24
S23
S22
S21
S20
S19
S18
S17
S16
S15
S14
S13
S12
S11
S10
4
P30/TO0
P31/TI00
P32/TI01
P33/TO50/TI50
P34/TO51/TI51
P20/RXD0/SI3
P21/TXD0/SO3
P22/SCK3
P23/SI1
P24/SO1
P25/SCK1
P00/INTP0
P01/INTP1
P02/INTP2
P03/INTP3/ADTRG
P04/INTP4
P05/INTP5/BUZ/PCL
VPP
XT2
XT1
VSS1
VDD1
X2
X1
RESET
AVREF0
P10/ANI0
P11/ANI1
P12/ANI2
P13/ANI3
5
S641 SW-167 (SKQT)
NC
1
2
VSSTB
3
EXSTB
4
5
6
ERXDI
7
ETXDO
8
9
10
11
SCLK
12
13
14
15
16
17
CSIFT
18
19
20
21
22
23
24
OSC1
25
26
WDECV 27
EXDET 28
29
30
C504
0.0015
S104 EVQP2T02M
C412 0.47
R412 10 k
C413
0.1
3
R603
12 k
R606
1k
S101
EVQP2T02M
CD
C591
0.01
C612
0.022
R612
4.7 k
R415
1.5 M
C268 0.047
R273 1 k
S5V
R659
680
R657
680
R654
680
R652
220
R663
220
R658 1 k
R656
1k
R653 1 k
R651
330
R662
330
DS658
DS659
SML-311YT SML-311YT
DS656
DS657
SML-311YT SML-311YT
DS654
SML-311YT
5
D601
R605
MA2S077 12 k
S5V
R691
ERJ2GE-JPW
IC581
S-80942CNMC-G9C
10
9
8
7
6
2
C661
0.047
Q653
XP1213
R521
R690
680 ERJ2GE-JPW
1
2 OUT
3 VDD
VSS
POUT
PWGND
PREGND
PHASE
NF
Q651
XP1213
C602
7P
MIC1
Q501
UNR9213J
IC421 TA7368F
1
C664
0.047
3
R513
18 k
NC
VCC
NC
VIN
RIPPLE
DS653
SML-311YT
C601
22 P
MIC2
RES
ESCK
ESDA
C581
0.027
C611 0.001
R276
10 k
C266
150 P
C265
0.001
EP682 CV1083
C662
0.001
4
C512 0.1
S102 EVQP2T02M
R283
100 k
DETOUT
DETIN
R581 10 k
IC282
TC4W53FU
TLED
RLED
R471
680 k
2
Q411
2SC4213 B
ATIS
7
R705
18 k
1
R611
10 k
S100 EVQP2T02M
AFOUT
CPU5V
SPG
S5V
RES
5
R474
5.6 k
5
R512
150 k
MODIN
R704 100 k
R511
27 k
R5V
C511
0.0033
MODIN
R399
ERJ2GE-JPW
1
2
3
4
5
VPP
4
R707
8.2 k
C503
0.0047
CTFIS
R632
100 k
5
C502
150 P
C522
0.022
R708
3.9 k
MIC3
R503
120 k
C302
0.0022
R263
47 k
R264
8.2 k
S5V
ESDA
2
R414
1.5 M
C411
0.47
ESCK
6
R411
10 k
ETXDO
1
IC261
NJM12902V
Q654 UNR9213J
R502
33 k
C521
0.1
R701
390 k
R689 47 k
CDECV
WDECV
C267
0.0047
R271 56 k
R269
100 k
AG3V
RXDEC
R501
100 k
R463
5.6 k
R688 82 k
R504
10 k
R702 22 k
VPP
R441 470 k
R494 10 k
IC683
TA75S01F
1
C491
0.01
D603
MA2S111
6
R490
56 k
2
R298
4.7 k
R706 150 k
1
2
R482 100 k
EXDET
R686
1k
3
5
SMICO
R496
220 k
Q444
UNR9213J
R687
1k
R277
390 k
ERXDI
R709
4.7 k
C690
0.018
Q652
DTC144TU
4
MICMS
C463
0.01
Q656 XP4313
C481
0.01
IC682
TC4W66FU
3
R685
15 k
C695 1
R442
470 k
D602
DA221
R692
ERJ2GE-JPW
ETXDO
ERXDI
Q441 2SC4116 BL
R584 100 k
J414
14FH-SM1-TB
R481
100 k
Q442 RSR025N03
R297
10 k
R476 3.9 k
1
8
7
6
5
MICO
2
6
C301
0.022
C281
0.01
DETMS
R475 22 k
S5V
R296
15 k
1
2
3
4
R583
100 k
5
10
STXMS
C696
0.1
3
R275 C269
180 k 0.01
R274
1k
R477 2.2 k
C462
0.1
4
R306 68 k
R305
100 k
C687 47 P
Q291
XP4601
R307
1.2 k
IC281
TC4W66FU
8
R703 1.8 M
SPG
R270
15 k
C472 10
R718
1k
8
7
6
5
C686 47 P
AFOUT
R443
100 k
14
VOXT
8
7
6
5
R267
10 k
R266
5.6 k
C263
0.047
13
C693 0.001
Q443 RSR025N03
R700 1.2 k
R282
100 k
R398
ERJ2GE-JPW
12
9
R472
18 k
R473
4.7 k
R467
270
C697 0.1
R293
68 k
R272
150 k
C473
0.01
1
2
3
4
IC261
NJM12902V
R710
8.2 k
C465
1
1
2
SRXMS 3
4
R698 15 k
Q461
UNR9111J
IC261
NJM12902V
R712 4.7 k
EXPTT
C689
0.001
S5V
C293
0.033
R462
4.7 k
R292
68 k
R294
10 k
R5V
R699 330 k
SPGO
AFOUT
C294
0.0018
C272
0.47
R284
100 k
R261
R265 4.7 k
10 k
C261 C262
0.015 0.033
C692 470 P
DET
R281
100 k
R291 68 k
R262
12 k
PTTM
RLED
TLED
EXMIC
EXDET
C441 47 P
C291
0.01
11
C467 10
C698 0.001
ISPMS
R720
ERJ2GE-JPW
C292
0.0068
V+
GND
R697 100 k
Q462
UNR9111J
C464 1
C699
0.001
4 3
4
R696 100 k
INMIC
C688 0.1
R695 100 k
15
J412
BM02B-ASRS-TF
VOXM
C700 1
PTTIN
C461
0.001
R468 100 k
C466 0.1
MC461
1
2
3
4
5
6
7
8
9
10
11
12
13
14
R461
33 k
to the
MIC J415
1
2
S461
SKHLLFA010
16
SECTION 11
VOLTAGE DIAGRAM
11-1 MAIN UNIT
A
B
C
SRXMS
DET
R5V
CTFIS
DETMS
MODIN
S5V
4
IC261 NJM12902V
C270
0.01
S5V
DS681 A0286
D
CONT2
CONT1
E
R682
270 k
VOXT
WDECV
CPU5V
C606
0.01
F
CKSIS
CPU5V
AF7V
WDECV
BEEPO
BTYPE
CDECV
BATTY
A
B
C
SRXMS
DET
R5V
NOTES :
Contorol line
Common line
TX line
CTFIS
DETMS
MODIN
C129
0.001
R121 15 k
R131 82 k
C132 22 P
D132
1SS375
C138
0.5 P
C136 9 P
C134 24 P
C151 9 P
C152
10 P
D151 1SV307
C153
3P
D152 MA2S077
C155
0.001
R132
15 k
C137
0.001
TDETV
R133
10 k
D153
1SV308
C158
0.001
R154
10 k
C162
0.001
L156
56 nH [GM1600]
47 nH [GM1600E]
R151 100
L153
1 H
T1CON
J352
IMSA-9230B-1-06Z032-PT1
1
2
3
4
5
6
D41
SB20-03P
R571 330 k
C282
0.001
CP283
R693
1k
R572
150 k
R434 2.2 k
5
6
4
3
BTYPEI
AFVS
2
CP282
BATTV
C571
0.01
CPU5V
R553
22 k
VOLIN
VOLO
AF7V
R435 3.3 k
C431 1
C554
0.01
4
XP6501 AB
R431
27 k
5
R432 1 M
R433 Q432
2.2 k
1
VIN
VOUT
Q431
2SB1132 Q
C432 0.1
Q553
UNR9213J
1
2 CTRL
3 GND
NB
C557
22
5
4
3
2
Q552
XP6501 AB
VCC
IC551 NJM2870
C556
0.001
R326
4.7 k
C555
0.22
R324
4.7 k
C322
0.01
V5VS
S5VS
R323
10 k
R552
2.2 k
R322
4.7 k
R321
10 k
R551
10 k
R325
10 k
C324
0.01
R561
10 k
T5VS
R562
4.7 k
T5V
C326
4.7
S5V
Q323
2SA1588 GR
6
Q322
2SA1588 GR
M5VS
Q321
2SA1588 GR
C553 10
C552
0.001
Q551
2SB1132 Q
TDETV
11 - 2
C135
7P
L151
50 nH
VCC
1
V5V
C561
0.01
CPU5V
AF7V
WDECV
BEEPO
BTYPE
CDECV
BATTY
C121
56 P C122
39 P
C127
0.001
C126
18 P
C125
15 P
C142
0.001
R145
12 k
T1CON
R153
220 k
C154
0.001
D154
HVC350B
L154
56 nH
C159
C157 2.5 P
27 P
C161
56 P
R155
220 k
D155
HVC350B
C160
1P
L152
47 nH
C156
6P
CP131
R149 1 k
D121
RB706F-40
R114
100 k
C112
0.001
C113
0.1
C145 0.001
D141
MA2S728
R142
39 k
C141
0.1
R148 100
C133
11 P
L123
50 nH
C168
6 P [GM1600]
8 P [GM1600E]
R156
10 k
T2CON
M5V
Q561
2SA1588 GR
AFMS
CKSIS
C123
24 P
MP111
R113
4.7 k
R112 10
C107
22 P
R102
33 k
C104
0.1
C105
0.001
C144
0.01
R172 470 k
R173 5.6 k
C163
4P
L155
56 nH
C128
47 P
C115
0.001
C114
47 P
R101
4.7 k
C99
0.001
R98 100
R95 470
R94
1.5 k
R174 680 k
D171
MA2S111
R175
10 k
M5V
C323
0.01
QS
R146
10 k
C143
0.1
L132
32 nH
VCC
M5V
EXOEO
SQLT
VCOS
TXMS
ATTS
IC341 BU4094BCFV
C131 L131
D131
1SV307 0.001 30 nH
T5V
R5VS
V+
OE
Q5
Q6
Q7
Q8
R103
68
L92
0.1 H
C98
0.001
R96
3.3 k
C97
47 P
C92 0.001
R93
10 k
R91 1 k
C91 9 P
D92
MA77
R165
100 k [GM1600]
18 k [GM1600E]
C165 0.01
C166 47 P
R167
470
R181 C181
820 0.001
C182
82 P
R182 220 k
D181
HVC350B
C187
0.001
R5V
C341
0.01
STR
D
CLK
Q1
Q2
Q3
Q4
GND
16
15
14
13
12
11
10
9
Q111
RD07MVS1
C124
0.001
S5V
EXOEO
EXSTBO
DASTBO
SCLKO
SDATAO
FRCON
1
2
3
4
5
6
7
8
C111
100 P
Q141
UNR9113J
C164
7P
S5V
EXSTBO
SDATAO
SCLKO
CTFIS
SRXMS
DETMS
CKSIS
L121
L122
8.5 nH 10.5 nH
R111 10
R144 2.7 k
T3CON
R183
10 k
R143
2.2 k
R147
150 k
R122
150
1
R152
22 k [GM1600]
100 k [GM1600E]
R251 470
C251
0.01
T4CON
24 DA5V
T3CON
23
22
21
20
19
18
17
16
T2CON
15
14
T1CON
13
C252
0.01
VIN8
VOUT8
VOUT7
VIN7
GND
RESET
VDAREF
DO
VIN6
VOUT6
VOUT5
VIN5
C253
0.01
VIN1
VOUT1
VOUT2
VIN2
VDD
LD
CLK
DI
VIN3
VOUT3
VOUT4
VIN4
3
1
2
3
4
5
6
7
8
9
10
11
12
C184
2.5 P
C185
1P
R184
220 k
C186 D182
33 P HVC350B
C188
6P
L181
56 nH
R194
4.7 k
C189
5P
R191 120
C191
0.001
C192
47 P
Q191
3SK299 U73
L166
56 nH
C167
0.01
C201
0.001
R205
470
L203
0.1 H
R203
470
R206 4.7 k
C193
56 P
L191
0.47 H
R193
3.3 k
R202
10 k
Q165
3SK294
R185
10 k
RSSIV
NOISV
F
C202
27 P
R204
12
C203
8P
T4CON
IC251
M62363FP-650C
C246
470 P
C211 R211
0.001 1 k
R213
1 k [GM1600]
1.5 k [GM1600E]
SQLOUT
SQCON
MOCON
MODIN
S5V
DASTBO
SCLKO
SDATAO
L165
1 H
6
3
GND 1
IN
5
C213
9 P [GM1600]
6 P [GM1600E]
2
4 OUT
GND
Q324
XP1213
DET
C195
0.001
C194
0.022
C215
0.001
C216
0.01
R215 120 k
R216 680
Q211
2SC4215 O
Q232
2SC5107 O
R246
47 k
4
5
2
1
FI211
FL-377 [GM1600]
FL-355 [GM1600E]
C217
100 P
R245
47 k
Q231
UNR9113J
C210 4.7
R214
470
R232 47
X231
CDBC450CX24
R231
3.3 k
C245
0.001
MOCON
R244
2.2 k
C232
100 P
C231
0.001
C247
0.001
C244
0.001
R242
390
C243
0.001
C242 0.001
C241
0.1
C238 330 P
R247
1.2 k
R241 2.2 k
MIXIN
GND
N-REC
N-DET
RSSI
IFOUT
QUAD
AFOUT
16
15
NOISV
14
13
12 RSSIV
11
10
9
DET
R5V
W/NS
C240
0.001
C239
4.7
OSCIN
OSCOUT
MIXOUT
VCC
IFIN
DEC
FILOUT
FILIN
R239
330 k
R240 27 k
C235
0.1
C234
0.1
I
R237
12 k
R235
22 k
D232
DAN222
W/NS
C233
0.1
1
2
3
4
5
6
7
8
C237
330 P
R243
4.7
R234
22 k
R233
15 k
O
R236
4.7
L222
0.82 H
C223 18 P
IC231 TA31136FN
FI232
CFWM450G
I
R223
150
FI231
CFWM450E
O
D231
DAN222
C226
7P
R238 15 k C236 0.01
Q221
2SC4116 GR
C225 22 P
C224
2P
L221
1 H
R221 680 k
C222 0.01
C221
10 P
R222
1.2 k
R5V
C183
0.001
PLLIN
R201
1k
R192
100
1STLO
C171
0.47
R141
150 k
1
R171
10 k
C75
56 P
PLLIN
RSSIV
D
3
4
Q171
2SK1829
S5V
C103
15 P
2
VCOS
2
L124
2.7 H
L112
31 nH
IC141
TA75S01F
5
S5V
C74
56 P
R83 4.7 k
C72
0.001
L71
0.1 H
R71
68 k
1
2
3
Q82
UNR9213J
MP41
5
6
S5V
L72
33 nH
3
Q101
RD01MUS1
R393
ERJ2GE-JPW
Q91
2SC5110 O
Q71
2SC4215 Y
C71
2.5 P
C84 0.1
C83
47 P
R84
4.7 k
C82
12 P
R82
390
C73
8P
R5V
E
C96
0.001
R92
100
R64
47 k
C64
0.1
C63
0.001
L62
0.1 H
R61 100
L61
0.1 H
R62
68 k
1
5
L82
3.3 H
C54
18 P
R72
220
C173
47 P
C172
0.001
C35
470 P
R39
100 k
C37
1.5 P
3
2
C51
D39
1SV245 0.75 P
S5V
C45
0.01
C44
470 P
R81
330
C81
12 P
C56
0.01
R51
2.7 k
C52
5P
C32
8P
R33 1 k
4
Q51
2SC4226 R25
C53
22 P
R38 C36
47 k 1
Q81 XP1214
Q62
2SC4215 Y
4
L102
18 nH
R394
ERJ2GE-JPW
R391
D91
MA77 ERJ2GE-JPW
C65
18 P
C62 R63
7 P 4.7
Q61
2SC4215 Y
L81
3.3 H
C106
0.001
C100
5P
C57
0.5 P
R53 4.7 k
L51
0.1 H
C61
0.001
R41
1.5 k
R42
3.9 k
C41
2.5 P
D34
D32
HVC350B HVC350B
C39 5 P
R32
1k
L33
0.47 H
C43
12 P
V5FV
C55
470 P
C40 3.5 P
D40 1SV308
C42
47 P
R65
100
R166
270 k [GM1600]
150 k [GM1600E]
CP1
LOINV
C34
0.001
L34
82 nH
R35
180 k
D36
HVC350B R37
100 k
C46
0.75 P
Q655 UMD6
EP111
MPZ1608S221A
EP101
BLM11B221SB
C325
22
LOINV
R390
0
L35
39 nH
R34
10
2
D35
HVC350B
D38
HVC350B
D33
HVC350B
C33
33 P
R36
47 k
GND
R22
8.2 k
VCON
3
C12 10 P
OUT
R15 10 k
1
VCC
D37
HVC350B
Q3
2SK880 Y
X1
CR-783
4
C38 1
R21
10 k
C20 0.001
C13 100 P
C10
0.1
R6 220 k
R9
330 k
C19
0.001
REFIN
R40 4.7 k
ATTS
Q41
2SC4226 R25
R43
4.7
C31 L41
18 P 82 nH
R52
5.6 k
C16
4.7
PLLIN
IC1 MB15A02PFV-1
EP4 ACZ1005Y-102
R20 1 k
8
7
6
5
4
3
2
1
C21 0.001
R4
NTCG16 4LH 473KT
V5FV
R31 10
R16 56
EP3
ACZ1005Y-102
CLOCK
FIN
DATA
LD
LE
GND
FC
DO
VCC
NC
VP
FOUT
OSCOUT
P
OSCIN
B
D31
HVC350B
L31
ELJNC R47K 0.47U
R47 2.2 k
C14 0.001
9
10
11
12
13
14
15
16
C11
0.001
R5 100 k
EP2
ACZ1005Y-102
C5 0.1
1
V5FV
L32
68 nH [GM1600]
27 nH [GM1600E]
SCLKO
SDATAO
PLSTBO
S5V
TEMPV
6
D1 MA2S111
UNLKI
S5V
C4
47 P
C3
0.001
C2
0.1
C1 0.1
R1
150 k
2
Q47
XP6501 AB
PLL5V
S5V
3
5
C48 10
C17
1.5
R18
1k
R2
22
R17
100
4
C47 10
R19 470
R97 10
RX line
1
2
3
4
5
6
1-1-32, Kamiminami, Hirano-ku, Osaka 547-0003, Japan
Phone : +81 (06) 6793 5302
Fax
: +81 (06) 6793 0013
URL : http://www.icom.co.jp/world/index.html
<Corporate Headquarters>
2380 116th Avenue N.E., Bellevue, WA 98004, U.S.A.
Phone : +1 (425) 454-8155
Fax : +1 (425) 454-1509
URL : http://www.icomamerica.com
E-mail : [email protected]
<Customer Service>
Phone : +1 (425) 454-7619
Glenwood Centre #150-6165
Highway 17 Delta, B.C., V4K 5B8, Canada
Phone : +1 (604) 952-4266
Fax : +1 (604) 952-0090
URL : http://www.icomcanada.com
E-mail : [email protected]
A.B.N. 88 006 092 575
Unit 1 / 103 Garden Road, Clayton VIC 3168 Australia
Phone : +61 (03) 9549-7500
Fax : +61 (03) 9549-7505
URL : http://www.icom.net.au
E-mail : [email protected]
146A Harris Road, East Tamaki,
Auckland, New Zealand
Phone : +64 (09) 274 4062
URL : http://www.icom.co.nz
E-mail : [email protected]
Communication Equipment
Himmelgeister Str. 100, D-40225 Dusseldorf, Germany
Phone : +49 (0211) 346047
Fax : +49 (0211) 333639
URL : http://www.icomeurope.com
E-mail : [email protected]
Crta. de Gracia a Manresa Km. 14,750
08190 Sant Cugat del Valles Barcelona, SPAIN
Phone : +34 (93) 590 26 70
Fax : +34 (93) 589 04 46
URL : http://www.icomspain.com
E-mail : [email protected]
Unit 9, Sea St., Herne Bay, Kent, CT6 8LD, U.K.
Phone : +44 (01227) 741741
Fax : +44 (01227) 741742
URL : http://www.icomuk.co.uk
E-mail : [email protected]
Zac de la Plaine, 1, Rue Brindejonc des Moulinais
BP 5804, 31505 Toulouse Cedex, France
Phone : +33 (5) 61 36 03 03
Fax : +33 (5) 61 36 03 00
URL : http://www.icom-france.com
E-mail : [email protected]
Fax : +64 (09) 274 4708
Room C07, 10th Floor, Long Silver Mansion, No. 88,
Yong Ding Road, Haidian District, Beijing, 100039, China
Phone : +86 (010) 5889 5391/5392/5393
Fax
: +86 (010) 5889 5395
URL : http://www.bjicom.com
E-mail : [email protected]
6F No.68, Sec. 1 Cheng-Teh Road, Taipei, Taiwan, R.O.C.
Phone : +886 (02) 2559 1899
Fax : +886 (02) 2559 1874
URL : http://www.asia-icom.com
E-mail : [email protected]
Sopot, 3 Maja 54 Poland
Phone : +48 (58) 550 7135
Fax : +48 (58) 551 0484
E-mail : [email protected]
S-141221Z-C1-q
© 2005 Icom Inc.

Top types

Top brands

Top types

Top brands

Top types

Top brands

Top types

Top brands

Top types

Top brands

Top types

Top brands

Top types

Top brands

Top types

Top brands

Top types

Top brands

Top types

Top brands

Top types

Top brands

Top types

Top brands

Top types

Top brands

Download Icom IC-GM1600 User's Manual