Download E:\User Guide\SVC MANUAL\수출 SV
Transcript
GSM TELEPHONE GT-C3510 GSM TELEPHONE CONTENTS 1. Safety Precautions 2. Specification 3. Product Function 4. Array course control 5. Exploded View and Parts list 6. MAIN Electrical Parts List 7. Block Diagrams 8. PCB Diagrams 9. Chart of Troubleshooting 10. Reference data 11. Disassembly and Assembly Instructions GSPN (Global Service Partner Network) Country Web Site North America service.samsungportal.com Latin America latin.samsungportal.com CIS cis.samsungportal.com Europe europe.samsungportal.com China china.samsungportal.com Asia asia.samsungportal.com Mideast & Africa mea.samsungportal.com This Service Manual is a property of Samsung Electronics Co.,Ltd. Any unauthorized use of Manual can be punished under applicable International and/or domestic law. ⓒ Samsung Electronics Co.,Ltd. 2009. 12. Rev.1.0 11. Disassembly and Assembly Instructions 11-1. Disassembly 1 1) Unscrew the 6 points. 2 1) Separate the rear case. Be careful not to damage the SMD material. Don't use DISASSEMBLE JIG deeply. ※ Caution ※ Caution 1) Be careful not to make scratch and molding 1) Be careful not to make scratch and molding damage. 3 damage. 1) Perform TSP FPCB visual check 4 1) Separate the LCD connectors, then unhook at the 4 points. After disassembling the rear case, check the TSP FPCB damage. ※ Caution 1) Be careful not to make damage to INTENNA ※ Caution 1) Be careful not to make scratch and molding damage. 11-1 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Exploded View and Parts List 5 1) After lifting PBA upward, 6 1) Separate PBA and the front Assembly. disassemble TSP FPCB under the board. ※ Caution ※ Caution 1) Be careful not to make scratch and molding damage. 7 1) Be careful not to make scratch and molding damage. 2) Be careful not to damage the PBA. 8 1) Separate bracket hooks on 3 points ※ Caution 1) Be careful not to damage LCD FPCB. 1) Lift LCD top and separate it from the front case. 2) Separate LCD connector from the bracket. ※ Caution 11-2 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Exploded View and Parts List 9 1) Disassemble intenna's left/right hooks 10 on 2 points. 1) Separate camera connector. 2) Disassemble SPK Carrier's left/right hooks on 2 points and remove solder. ※ Caution ※ Caution 1) Be careful not to make intenna hook damage. 11 1) Be careful not to make SPK Hook damage. 12 1) Remove RCV/MIC solder. 1) Remove screw at 1point 2) Separate the motor/shield can from the PBA. ※ Caution 1) Be careful not to damage FPCB. ※ Caution 11-3 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Exploded View and Parts List 11-2. Assembly 1 1) Assemble the shield can and screw at 1point 2) Solder the motor 1) Solder the receiver and Mic. ※ Caution ※ Caution 1) Be careful not to damage the FPCB. 3 2 1) Solder and assemble the speaker module and PBA. ※ Caution 1) Confirm receiver's location 2) Be careful not to make SPK Hook damage. 1) Be careful not to damage the receiver FPCB & SPK WIRE. 4 1) Assemble the camera carrier. 2) Assemble the motor. ※ Caution 1) Be careful not to damage PBA. 11-4 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Exploded View and Parts List 5 6 1) Assemble the Intenna to PBA 1) Attach the TSP. 2) Assemble the keypad ※ Caution ※ Caution 1) Be careful not to make Intenna hook damage. 7 1) Be careful not to damage the motor wire . 8 1) Attach and assemble the LCD 1) Assemble the bracket. ※ Caution ※ Caution 1) Be careful not to damage LCD. 1) Be careful not to damage to LCD connector. 11-5 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Exploded View and Parts List 9 1) Assemble TSP FPCB to PBA connector. 10 1) Locate and make sure of assembly hooks after placing PBA on the top. 2) Assemble LCD connector ※ Caution ※ Caution 1) Be careful not to make scratch and molding 1) Be careful not to damage TSP FPCB. damage. 2) Be careful not to damage TSP FPCB. 11 1) Confirm assembly hooks after assembling 12 1) Screw at 6 points the rear case. ※ Caution ※ Caution 1) Be careful not to make scratch and molding 1) Be careful not to make scratch and molding damage. damage. 11-6 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization 6. MAIN Electrical Parts List SEC CODE DESIGN LOC DESCRIPTION 0403-001547 ZD301 DIODE-ZENER 0406-001286 ZD405 DIODE-TVS 0406-001286 ZD406 DIODE-TVS 0406-001293 ZD400 DIODE-TVS 0406-001293 ZD402 DIODE-TVS 0406-001293 ZD500 DIODE-TVS 0406-001293 ZD501 DIODE-TVS 0406-001293 ZD502 DIODE-TVS 0406-001293 ZD503 DIODE-TVS 0406-001329 D400 DIODE-TVS 0406-001361 ZD300 DIODE-TVS 0505-001325 Q400 FET-SILICON 1003-002047 U400 IC-MOTOR DRIVER 1108-000297 UME200 IC-MCP 1201-002933 PAM100 IC-POWER AMP 1203-005728 U302 IC-POWER SUPERVISOR 1203-005770 U300 IC-MULTI REG 1203-006077 U301 IC-BACKLIGHT DRIVER 1205-003310 U103 IC-TRANSCEIVER 1205-003874 UCP200 IC-MODEM 1205-003883 U100 IC-BLUETOOTH 1404-001221 VR200 THERMISTOR-NTC 2007-000140 R207 R-CHIP 2007-000141 R303 R-CHIP 2007-000141 R401 R-CHIP 2007-000141 R409 R-CHIP 2007-000141 R416 R-CHIP 2007-000141 R420 R-CHIP 2007-000143 R309 R-CHIP 2007-000143 R402 R-CHIP 2007-000143 R417 R-CHIP 2007-000148 R104 R-CHIP 2007-000148 R105 R-CHIP 2007-000148 R315 R-CHIP 2007-000149 R206 R-CHIP 2007-000149 R314 R-CHIP 2007-000152 R318 R-CHIP 6-1 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Main Electrical Parts List SEC CODE DESIGN LOC DESCRIPTION 2007-000152 R319 R-CHIP 2007-000152 R427 R-CHIP 2007-000157 R107 R-CHIP 2007-000157 R108 R-CHIP 2007-000157 R313 R-CHIP 2007-000159 R310 R-CHIP 2007-000159 R311 R-CHIP 2007-000159 R312 R-CHIP 2007-000159 R316 R-CHIP 2007-000160 R100 R-CHIP 2007-000160 R200 R-CHIP 2007-000165 R425 R-CHIP 2007-000166 R317 R-CHIP 2007-000170 R407 R-CHIP 2007-000170 R415 R-CHIP 2007-000170 R426 R-CHIP 2007-000173 R320 R-CHIP 2007-000566 R201 R-CHIP 2007-001292 R300 R-CHIP 2007-001292 R301 R-CHIP 2007-001319 R202 R-CHIP 2007-001319 R203 R-CHIP 2007-001319 R204 R-CHIP 2007-001319 U401 R-CHIP 2007-001333 R304 R-CHIP 2007-001333 R306 R-CHIP 2007-001333 R429 R-CHIP 2007-001333 R440 R-CHIP 2007-001339 R307 R-CHIP 2007-002970 R102 R-CHIP 2007-002970 R103 R-CHIP 2007-007573 R302 R-CHIP 2007-007875 R308 R-CHIP 2007-008354 R305 R-CHIP 2203-000233 C106 C-CER,CHIP 2203-000233 C400 C-CER,CHIP 2203-000233 C509 C-CER,CHIP 6-2 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Main Electrical Parts List SEC CODE DESIGN LOC DESCRIPTION 2203-000254 C108 C-CER,CHIP 2203-000254 C111 C-CER,CHIP 2203-000254 C203 C-CER,CHIP 2203-000311 C340 C-CER,CHIP 2203-000386 C335 C-CER,CHIP 2203-000386 C338 C-CER,CHIP 2203-000386 C401 C-CER,CHIP 2203-000386 C402 C-CER,CHIP 2203-000386 C410 C-CER,CHIP 2203-000386 C411 C-CER,CHIP 2203-000386 C431 C-CER,CHIP 2203-000386 C432 C-CER,CHIP 2203-000438 C209 C-CER,CHIP 2203-000438 C437 C-CER,CHIP 2203-000438 C438 C-CER,CHIP 2203-000585 C428 C-CER,CHIP 2203-000585 C433 C-CER,CHIP 2203-000585 C434 C-CER,CHIP 2203-000679 C117 C-CER,CHIP 2203-000725 C423 C-CER,CHIP 2203-000812 C103 C-CER,CHIP 2203-000812 C105 C-CER,CHIP 2203-000812 C144 C-CER,CHIP 2203-000812 C148 C-CER,CHIP 2203-000854 C348 C-CER,CHIP 2203-000854 C349 C-CER,CHIP 2203-000854 C405 C-CER,CHIP 2203-000854 C414 C-CER,CHIP 2203-000995 C134 C-CER,CHIP 2203-002709 C429 C-CER,CHIP 2203-002709 C430 C-CER,CHIP 2203-005050 C114 C-CER,CHIP 2203-005053 C121 C-CER,CHIP 2203-005234 C147 C-CER,CHIP 2203-005281 C123 C-CER,CHIP 2203-005281 C128 C-CER,CHIP 2203-005288 C101 C-CER,CHIP 6-3 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Main Electrical Parts List SEC CODE DESIGN LOC DESCRIPTION 2203-005288 C120 C-CER,CHIP 2203-005288 C122 C-CER,CHIP 2203-005395 C100 C-CER,CHIP 2203-005450 C202 C-CER,CHIP 2203-005450 C207 C-CER,CHIP 2203-005480 C320 C-CER,CHIP 2203-005480 C322 C-CER,CHIP 2203-005483 C215 C-CER,CHIP 2203-006048 C107 C-CER,CHIP 2203-006048 C130 C-CER,CHIP 2203-006048 C133 C-CER,CHIP 2203-006048 C201 C-CER,CHIP 2203-006048 C204 C-CER,CHIP 2203-006048 C206 C-CER,CHIP 2203-006048 C208 C-CER,CHIP 2203-006048 C210 C-CER,CHIP 2203-006048 C211 C-CER,CHIP 2203-006048 C316 C-CER,CHIP 2203-006048 C326 C-CER,CHIP 2203-006048 C336 C-CER,CHIP 2203-006048 C347 C-CER,CHIP 2203-006048 C351 C-CER,CHIP 2203-006048 C353 C-CER,CHIP 2203-006048 C403 C-CER,CHIP 2203-006048 C406 C-CER,CHIP 2203-006048 C412 C-CER,CHIP 2203-006048 C415 C-CER,CHIP 2203-006190 C124 C-CER,CHIP 2203-006190 C125 C-CER,CHIP 2203-006190 C314 C-CER,CHIP 2203-006190 C315 C-CER,CHIP 2203-006201 C307 C-CER,CHIP 2203-006257 C113 C-CER,CHIP 2203-006260 C313 C-CER,CHIP 2203-006260 C323 C-CER,CHIP 2203-006260 C325 C-CER,CHIP 2203-006348 C301 C-CER,CHIP 6-4 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Main Electrical Parts List SEC CODE DESIGN LOC DESCRIPTION 2203-006399 C200 C-CER,CHIP 2203-006399 C212 C-CER,CHIP 2203-006399 C213 C-CER,CHIP 2203-006399 C300 C-CER,CHIP 2203-006399 C302 C-CER,CHIP 2203-006399 C303 C-CER,CHIP 2203-006399 C304 C-CER,CHIP 2203-006399 C305 C-CER,CHIP 2203-006399 C308 C-CER,CHIP 2203-006399 C309 C-CER,CHIP 2203-006399 C310 C-CER,CHIP 2203-006399 C311 C-CER,CHIP 2203-006399 C312 C-CER,CHIP 2203-006399 C321 C-CER,CHIP 2203-006399 C328 C-CER,CHIP 2203-006399 C339 C-CER,CHIP 2203-006399 C350 C-CER,CHIP 2203-006399 C421 C-CER,CHIP 2203-006399 C500 C-CER,CHIP 2203-006399 C501 C-CER,CHIP 2203-006399 C502 C-CER,CHIP 2203-006399 C503 C-CER,CHIP 2203-006399 C504 C-CER,CHIP 2203-006562 C317 C-CER,CHIP 2203-006562 C324 C-CER,CHIP 2203-006562 C327 C-CER,CHIP 2203-006824 C343 C-CER,CHIP 2203-006824 C344 C-CER,CHIP 2203-006838 C205 C-CER,CHIP 2203-006838 C214 C-CER,CHIP 2203-006838 C306 C-CER,CHIP 2203-006872 C109 C-CER,CHIP 2203-006872 C110 C-CER,CHIP 2203-006872 C112 C-CER,CHIP 2203-006872 C115 C-CER,CHIP 2203-006890 C217 C-CER,CHIP 2203-006890 C318 C-CER,CHIP 6-5 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Main Electrical Parts List SEC CODE DESIGN LOC DESCRIPTION 2203-006890 C330 C-CER,CHIP 2203-007279 C104 C-CER,CHIP 2203-007279 C341 C-CER,CHIP 2203-007279 C342 C-CER,CHIP 2203-007279 C352 C-CER,CHIP 2203-007279 C418 C-CER,CHIP 2203-007317 C345 C-CER,CHIP 2203-007425 C337 C-CER,CHIP 2203-007425 C439 C-CER,CHIP 2404-001377 C319 C-TA,CHIP 2404-001377 TA400 C-TA,CHIP 2404-001496 TA300 C-TA,CHIP 2409-001172 BAT300 C-ETC 2703-002170 L110 INDUCTOR-SMD 2703-002170 L113 INDUCTOR-SMD 2703-002202 L111 INDUCTOR-SMD 2703-002202 L112 INDUCTOR-SMD 2703-002202 L115 INDUCTOR-SMD 2703-002203 L109 INDUCTOR-SMD 2703-002207 L102 INDUCTOR-SMD 2703-002207 L120 INDUCTOR-SMD 2703-002208 L116 INDUCTOR-SMD 2703-002208 L121 INDUCTOR-SMD 2703-002268 L101 INDUCTOR-SMD 2703-002268 L103 INDUCTOR-SMD 2703-002269 L100 INDUCTOR-SMD 2703-002313 L106 INDUCTOR-SMD 2703-002313 L107 INDUCTOR-SMD 2703-002313 L406 INDUCTOR-SMD 2703-002313 L407 INDUCTOR-SMD 2703-002368 L118 INDUCTOR-SMD 2703-003121 L412 INDUCTOR-SMD 2703-003260 L300 INDUCTOR-SMD 2703-003476 L400 INDUCTOR-SMD 2801-004339 OSC300 CRYSTAL-SMD 2801-004893 OSC100 CRYSTAL-SMD 2901-001576 F500 FILTER-EMI/ESD 6-6 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Main Electrical Parts List SEC CODE DESIGN LOC DESCRIPTION 2901-001576 F501 FILTER-EMI/ESD 2901-001576 F502 FILTER-EMI/ESD 2901-001576 F503 FILTER-EMI/ESD 2901-001576 F504 FILTER-EMI/ESD 2904-001889 F102 FILTER-SAW 2904-001920 F101 FILTER-SAW 2909-001312 F100 FILTER-LC 3301-001659 L415 BEAD-SMD 3301-001659 L416 BEAD-SMD 3301-001659 L419 BEAD-SMD 3301-001659 L420 BEAD-SMD 3301-001729 L401 BEAD-SMD 3301-001729 L402 BEAD-SMD 3301-001729 L421 BEAD-SMD 3301-001729 L422 BEAD-SMD 3404-001152 TAC_CAM SWITCH-TACT 3404-001152 TAC_DN SWITCH-TACT 3404-001152 TAC_HOLD SWITCH-TACT 3404-001152 TAC_UP SWITCH-TACT 3705-001503 RFS100 CONNECTOR-COAXIAL 3708-002015 HDC500 CONNECTOR-FPC/FFC/PIC 3709-001447 SIM300 CONNECTOR-CARD EDGE 3709-001575 CD300 CONNECTOR-CARD EDGE 3710-002683 IFC400 SOCKET-INTERFACE 3711-005296 HDC503 HEADER-BOARD TO BOARD 3711-005793 HDC501 HEADER-BOARD TO BOARD 3711-006808 BTC300 HEADER-BATTERY 3722-003003 EAR400 JACK-EAR PHONE 4202-001463 ANT102 ANTENNA-CHIP GH70-04132A SC100 ICT SHIELD-CAN CLIP GH80-03320A R109 SHORT PAD GH80-03320A R208 SHORT PAD GH80-03320A R428 SHORT PAD Please consult the GSPN website (Samsung Portal) for the most recent version of the product's part list. 6-7 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization 5. Exploded View and Parts List 5-1. Cellular phone Exploded View QME03 QKP01 QFR01 QLC01 QLB01 QCR72 QAR01 QME01 QMP01 QMI01 QSH01 QSP01 QCA01 QMO01 QAN02 QCK02 QVO01 QCK01 QSD01 QRE01 QIF01 QCW01 QCR101 QBA01 QBC00 5-1 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization - This Document can not be used without Samsung's authorization - 5-2. Cellular phone Parts list : GT-C3510CWAXEF Design LOC Description SEC CODE QAN02 INTENNA-MAIN (GT-C3510) GH42-02300A QAR01 AUDIO-RECEIVER 3009-001428 QBA01 INNER BATTERY PACK-AB463651BU,960MAH GH43-03216A QBC00 ASSY COVER-BATT V3(OPTION) GH98-16285D QCA01 CAMERA MODULE-GT-C3510 GH59-08802A QCK01 ASSY KEY-CAM GH98-16235D QCK02 ASSY KEY-HOLD GH98-16234D QCR101 SCREW-MACHINE 6001-002005 QCR72 SCREW-MACHINE 6001-002051 QCW01 PCT WINDOW-CAMERA GH72-56746A QFR01 ASSY CASE-FRONT GH98-15114D QIF01 ASSY CASE-IF GH98-16231D QKP01 ASSY KEYPAD-(OPEN/WHITE) GH98-15117D QLB01 ASSY BRACKET-LCD GH98-15118A QLC01 ASSY LCD-2.8",TFT(GT-C3510) GH96-04335A QME01 DOME SHEET-GT-C3510(MAIN) GH59-08590A QME03 TOUCH/PANEL-GT-C3510(WHT) GH59-08654B QMI01 MICROPHONE-ASSY-GT-C3510 GH30-00627A QMO01 MOTOR LINEAR VIBRATION-GT_S7330 GH31-00449A QMP01 A/S ASSY-PBA MAIN,ECC,GT-C3510(SVC) GH82-04359A QRE01 ASSY CASE-REAR GH98-15116D QSD01 ASSY CASE-SD GH98-16232D QSP01 MODULE-SPKCARRIER ASSY(GT-C3510) GH59-08765A QVO01 ASSY KEY-VOL GH98-16233D 2. Specification 2-1. GSM General Specification GSM850 GSM900 DCS1 800 PCS1 900 F req. Band[ MHz] Uplink/Downlink 824~8 49 869~8 94 880~9 15 925~9 60 1710~1 785 1805~1 880 1850~1 910 1930~1 990 ARFCN r ange 128~2 51 0~1 24 & 975~1 023 512~8 85 512~8 10 Tx/Rx spa cing 45MHz 45MHz 95MHz 80MHz Mod. Bit rat e/ Bit Period 2 70.83 3kbps 3.69 2us 270.8 33kbps 3.69 2us 270.8 33kbps 3.69 2us 270.8 33kbps 3.69 2us T im e Sl ot Period/F rame Period 576. 9us 4 .615ms 576. 9us 4 .615ms 576. 9us 4 .615ms 576. 9us 4 .615ms Modulation 0.3G M SK 0.3G MSK 0.3G M SK 0.3G MSK MS Powe r 3 3dBm~5 dBm 33dBm~ 5dBm 30dBm~ 0dBm 30dBm~ 0dBm Power Class 4 ( m ax +33d Bm) 4 ( m ax +33d Bm) 1 ( m ax +30d Bm) 1 ( m ax +30d Bm) Sensit ivit y - 102dBm - 102dBm - 100dBm - 100dBm T DM A Mu x 8 8 8 8 Cell Radius 35Km 35Km 2Km 2Km 2-1 Speclflcation 2-2. GSM Tx Power Class TX Power TX Power TX Power control level GSM850 GSM900 control level 5 33±3 dBm 0 30±3 dBm 0 30±3 dBm 6 31±3 dBm 1 28±3 dBm 1 28±3 dBm 7 29±3 dBm 2 26±3 dBm 2 26±3 dBm 8 27±3 dBm 3 24±3 dBm 3 24±3 dBm 9 25±3 dBm 4 22±3 dBm 4 22±3 dBm 10 23±3 dBm 5 20±3 dBm 5 20±3 dBm 11 21±3 dBm 6 18±3 dBm 6 18±3 dBm 12 19±3 dBm 7 16±3 dBm 7 16±3 dBm 13 17±3 dBm 8 14±3 dBm 8 14±3 dBm 14 15±3 dBm 9 12±4 dBm 9 12±4 dBm 15 13±3 dBm 10 10±4 dBm 10 10±4 dBm 16 11±5 dBm 11 8±4dBm 11 8±4dBm 17 9±5 dBm 12 6±4 dBm 12 6±4 dBm 18 7±5 dBm 13 4±4 dBm 13 4±4 dBm 19 5±5 dBm 14 2±5 dBm 14 2±5 dBm 15 0±5 dBm 15 0±5 dBm 2-2 DCS1800 control level PCS1900 Speclflcation 2-3. GSM EDGE TX power class TX Power Only in Master TX Power TX Power control level GSM900 GSM850 control level 8 27±3 dBm 2 26±3 dBm 2 26±3 dBm 9 25±3 dBm 3 24±3 dBm 3 24±3 dBm 10 23±3 dBm 4 22±3 dBm 4 22±3 dBm 11 21±3 dBm 5 20±3 dBm 5 20±3 dBm 12 19±3 dBm 6 18±3 dBm 6 18±3 dBm 13 17±3 dBm 7 16±3 dBm 7 16±3 dBm 14 15±3 dBm 8 12±3 dBm 8 12±3 dBm 15 13±3 dBm 9 10±3 dBm 9 10±3 dBm 16 11±5 dBm 10 14±3 dBm 10 14±3 dBm 17 9±5 dBm 11 12±4 dBm 11 12±4 dBm 18 7±5 dBm 12 10±4 dBm 12 10±4 dBm 19 5±5 dBm 13 8±4dBm 13 8±4dBm 14 6±4 dBm 14 6±4 dBm 15 4±4 dBm 15 4±4 dBm 2-3 DCS1800 control level PCS1900 3. Operation Instruction and Installation Main Function - 1.3 Mega Pixel Camera - QVGA 2.8 inch TSP - SMS/MMS/EMS ( OMA v1.2 ) - WAP 2.0 Browser - MP3/AMR/AAC/AAC+/e-AAC+/WMA/i-melody - Quad Band(EGSM900/DCS,PCS,EDGE) - MicroSD Card Support - External Memory - USB v2.0 High-speed, Bluetooth v2.1 - FM Radio Support, Radio Data System 3-1 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization 4. Array course control 4-1. Software Adjustments Test Cable (GH39-01313A) Test Jig (GH99-36900A) RF Test Cable (GH39-00985A) Adapter (GH99-38251A) 4-1 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Array course control 4-2. Software Downloading 4-2-1. Pre-requsite for Downloading • Downloader Program(PNX6517 OneNAND Downloader v0.1 for GT-B3410(Delphi)) • GT-C3510 Mobile Phone • Data Cable • Binary file, TFS file, CSC file 4-2-2. S/W Downloader Program ■ the binary download program by executing the "PNX6517 OneNAND Downloader v0.1 for GT-B3410(Delphi).exe" 1. Select the connected serial port and the rate of speed. 2. Select the check box, the mode you want to download. - if only binary file update is needed, check "BIN" - if only tfs file update is needed, check "TFS" 4-2 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Array course control - if only csc file update is needed, check "Common CSC ONLY" - if all file updates are needed, check both "BIN+TFS" and "with Common CSC" 3. Click the corresponding button to select the file(s) that you want to download. 4/5. Choose each binary/tfs/csc file, then click open button. 6/7. After all necessary binary/tfs/csc file(s) are selected, check "AutoDownLoader" and click "START" button. Then, connect a phone with test cable at the designated serial port. If connection is successful, the downloader will start with pre-downloading and continue to main downloading. 4-3 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Array course control 4-3. Memory Full Reset After download has completed, follow the below procedure for full memory reset. Full Reset : *2767*3855# 4-4 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization 10. Reference data Reference Abbreviate ― AAC: Advanced Audio Coding. ― AVC : Advanced Video Coding. ― BER : Bit Error Rate ― BPSK: Binary Phase Shift Keying ― CA : Conditional Access ― CDM : Code Division Multiplexing ― C/I : Carrier to Interference ― DMB : Digital Multimedia Broadcasting ― EN : European Standard ― ES : Elementary Stream ― ETSI: European Telecommunications Standards Institute ― MPEG: Moving Picture Experts Group ― PN : Pseudo-random Noise ― PS : Pilot Symbol ― QPSK: Quadrature Phase Shift Keying ― RS : Reed-Solomon ― SI : Service Information ― TDM : Time Division Multiplexing ― TS : Transport Stream 10-1 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization 1. Safety Precautions 1-1. Repair Precaution ― Repair in Shield Box, during detailed tuning. Take specially care of tuning or test, because specipicty of cellular phone is sensitive for surrounding interference(RF noise). ― Be careful to use a kind of magnetic object or tool, because performance of parts is damaged by the influence of magnetic force. ― Surely use a standard screwdriver when you disassemble this product, otherwise screw will be worn away. ― Use a thicken twisted wire when you measure level. A thicken twisted wire has low resistance, therefore error of measurement is few. ― Repair after separate Test Pack and Set because for short danger (for example an overcurrent and furious flames of parts etc) when you repair board in condition of connecting Test Pack and tuning on. ― Take specially care of soldering, because Land of PCB is small and weak in heat. ― Surely tune on/off while using AC power plug, because a repair of battery charger is dangerous when tuning ON/OFF PBA and Connector after disassembling charger. ― Don't use as you pleases after change other material than replacement registered on SEC System. Otherwise engineer in charge isn't charged with problem that you don't keep this rules. 1-1 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Safety Precautions 1-2. ESD(Electrostatically Sensitive Devices) Precaution Several semiconductor may be damaged easily by static electricity. Such parts are called by ESD (Electrostatically Sensitive Devices), for example IC,BGA chip etc. Read Precaution below. You can prevent from ESD damage by static electricity. ― Remove static electricity remained your body before you touch semiconductor or parts with semiconductor. There are ways that you touch an earthed place or wear static electricity prevention string on wrist. ― Use earthed soldering steel when you connect or disconnect ESD. ― Use soldering removing tool to break static electricity. , otherwise ESD will be damaged by static electricity. ― Don't unpack until you set up ESD on product. Because most of ESD are packed by box and aluminum plate to have conductive power,they are prevented from static electricity. ― You must maintain electric contact between ESD and place due to be set up until ESD is connected completely to the proper place or a circuit board. 1-2 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization 9. Flow Chart of Troubleshooting 9-1.Baseband 9-1-1Power ON ' Power On' does not work Yes Check the Battery Voltage is it more than 3.4V? No Change the Battery Yes No U302 C330(VISA) = 2.6V? Check the PMU related to VINT Yes No Check the Clock at C338 = 32KHz Resolder OSC300 Yes No C306(VDD_IO_LOW_1.8V) & C312(VDD_IO_HIGH_2.9V) = "H"? Check the related circuit Yes No L300(VDD_GSM_CORE_ 1.2V) = 1.2V? Check the VDD_GSM_CORE_1.2V circuit Yes Check for the clock at CLK = 26MHz? No Check the clock generation circuit (related to TCX101) Yes Check the initial operation Yes END 9-1 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting VDD_SD_3.3V VDD_IO_LOW_1.8V VDD_PLL_1.2V AVDD_2.6V VDD_TSP_2.9V VCC_SYN_2.8V AVDD_HFA_2.6V VDD_RX_TX_2.8V VDD_MOT_3.0V +VBUS VDD_CAM_IO_2.8V C301 VDD_IO_HIGH_2.9V C303 C302 C306 C305 C304 C307 VDD_USB_3.3V C308 C309 C310 C311 AUX_ON JACK_IN C300 C312 3PI_L 3PI_R R300 R301 VBAT MIC_BIAS_2.15V E11 E9 D8 C1 B2 D2 C11 A 11 A9 A3 E1 C5 A5 A7 B6 D12 MES_BATT M2 C3 B4 B10 B8 K6 K12 L5 M10 C320 C322 IN1 IN2 IN3 IN4 IN5 IN6 IN7 IN8 IN9 J5 H6 J7 H8 C325 EAR_N C327 INB1 INB2 K8 L9 SPK_N OSC300 U302 USBLDO VL VBIAS VISA VSAVE IRQB XIN XOUT SCL SDA LX FB REFBP ONKEYB RESETB PWREN1 PWREN2 G9 J9 TEST1 TEST2 C318 C319 M4 L3 +VBUS_DETECT F2 C321 F4 C7 B12 C326 D10 K4 G1 E3 C328 C330 H4 D4 E7 D6 L1 J3 F8 F6 G5 CLK32K TP300 INT_PMU BAT300 SCL SDA C336 ONKEY_N L300 RSTON VDD_GSM_CORE_1.2V R307 C340 C344 C342 C343 M6 G11 K2 M8 J 11 L7 C335 SIMOFFB SIMVCC CLK32K C9 E5 REF_ON_PMU VCORE_CTRL C341 C338 2 G3 G7 H10 RXINN K10 RXINP CHGIN CHGINB H2 J1 C339 R308 C345 C340 OSC300 R307 C335 C338 C330 C306 C3 0 5 C307 R3 0 1 R3 0 0 C3 2 0 C3 2 3 C30 3 C302 C304 C308 C326 C336 C3 2 1 C3 1 0 C3 0 1 C3 3 7 C341 C3 1 7 C343 C318 C3 0 9 C3 2 7 C3 2 5 C3 3 9 C3 2 2 C344 U3 0 2 C3 1 9 C4 2 2 C4 2 6 C34 2 C300 C3 1 1 R308 C3 1 2 L3 0 0 TA 3 0 0 ZD405 1 MICBIAS OUTN OUTP F12 F10 V_EXT_CHARGE HPL HPR C1N C1P H12 L11 SPK_P SIMOFFn VCC_SIM_3.0V REC1B REC2B INA1 INA2 C323 EAR_P R303 NC NC C317 1 2 TA300 A GND GND PGND1 PGND2 PGND3 VSS R305 B A TT B A TTB B A TTS D1VDD D2VDD D3VDD D4VDD D5VDD D6VDD HCVDD IOVDD L CVDD L PVDD RF1VDD RFVDD2 VB US C316 C337 EARSPK_LOUT EARSPK_ROUT R302 9-2 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization C345 Flow Chart of Troubleshooting 9-1-2. Initial Initial Failure Yes No U302 pin G5 (RSTON) ="H"? Check the circuit related to reset Yes Check the 16bit data signal & memory CE Yes END VDD_SD_3.3V VDD_IO_LOW_1.8V VDD_PLL_1.2V AVDD_2.6V VDD_TSP_2.9V VCC_SYN_2.8V AVDD_HFA_2.6V VDD_RX_TX_2.8V VDD_MOT_3.0V +VBUS VDD_CAM_IO_2.8V C301 VDD_IO_HIGH_2.9V C302 C303 C305 C304 C306 C307 VDD_USB_3.3V C308 C310 C309 C311 AUX_ON JACK_IN C300 C312 3PI_L 3PI_R R300 R301 VBAT E11 E9 D8 C1 B2 D2 C11 A 11 A9 A3 E1 C5 A5 A7 B6 D12 MIC_BIAS_2.15V M2 C3 B4 B10 B8 K6 K12 L5 M10 C320 C322 J5 H6 C323 EAR_P J7 H8 C325 EAR_N C327 K8 L9 SPK_N H12 L11 SPK_P F12 F10 V_EXT_CHARGE OSC300 C9 E5 REF_ON_PMU VCORE_CTRL G9 J9 HPL HPR MICBIAS SIMOFFB SIMVCC U302 USBLDO VL VBIAS VISA VSAVE C1N C1P OUTN OUTP CLK32K CHGIN CHGINB IRQB XIN XOUT SCL SDA LX FB REFBP ONKEYB RESETB PWREN1 PWREN2 TEST1 TEST2 C318 C319 M4 L3 +VBUS_DETECT F2 C321 H10 RXINN K10 RXINP INA1 INA2 INB1 INB2 G3 G7 F4 C7 B12 C326 D10 K4 G1 E3 C328 C330 H4 D4 E7 D6 L1 J3 F8 F6 G5 CLK32K TP300 INT_PMU BAT300 SCL SDA C336 ONKEY_N RSTON L300 VDD_GSM_CORE_1.2V R307 C340 C344 C342 SIMOFFn VCC_SIM_3.0V REC1B REC2B M6 G11 K2 M8 J 11 L7 C335 C343 C338 2 C341 1 H2 J1 IN1 IN2 IN3 IN4 IN5 IN6 IN7 IN8 IN9 R303 NC NC C317 1 2 TA300 AGND GND PGND1 PGND2 PGND3 VSS R305 B A TT B A TTB B A TTS D1VDD D2VDD D3VDD D4VDD D5VDD D6VDD HCVDD IOVDD L CVDD L PVDD RF1VDD RFVDD2 VB US C316 C337 EARSPK_LOUT EARSPK_ROUT R302 MES_BATT C339 R308 9-3 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization C345 Flow Chart of Troubleshooting 9-1-3. SIM Part Phone can't access SIM Card Yes No SIM300 pin 1 = "H"? Resolder or replace SIM501 Yes After Power ON, Check SIM_CLK Signal on pin 3 of SIM300 in a few second No Check the Clock Yes No After SIM card insert, SIM300 pin 2 = "H(SIM_RST)"? Resolder or replace UCP301 Yes Check the SIM Card Yes END 9-4 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting VCC_SIM_3.0V R314 SIM_IO 1 SIM_RST SIM_CLK C348 C349 2 3 1 2 3 7 8 9 7 8 9 6 6 5 5 4 4 12 12 11 11 10 10 G G G G 16 15 14 13 SIM300 C347 R429 C201 C209 TP2 1 0 R206 TP201 C210 C217 ZD406 I FC4 0 0 C4 1 8 C200 R207 C214 R320 R317 C350 C216 C202 R316 R309 C348 ZD300 C424 C347 L416 R312 R311 R314 R310 R4 4 0 C349 C417 R4 2 8 C438 TP109 C423 L415 R425 U400 C437 L4 0 6 R3 1 3 C4 2 1 L4 0 7 R2 0 2 R2 0 3 R2 0 4 U4 0 1 C328 C345 C3 2 0 C3 2 3 ZD405 SPK400 TAC_DN TAC_UP MO T4 00 SPK401 9-5 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization C343 BTC300 SIM300 C4 2 2 C4 2 6 C34 2 C335 U3 0 2 R3 0 1 C3 2 7 C3 2 5 C3 3 9 L402 ZD503 R307 C3 2 2 C413 OSC300 R308 R3 0 0 C410 C3 1 9 TA 3 0 0 R421 L3 0 0 Z D40 3 Z D40 4 L422 C340 Flow Chart of Troubleshooting 9-1-4. Charging Part Abnormal charging part Yes No Check the U302 pin F10, F12 > 4.9V Check the circuit related to V_EXT_CHARGE Yes No U302 pin G3 (AUX_ON) = "L"? Check the circuit related to AUX_ON signal Yes END 9-6 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting VDD_SD_3.3V VDD_IO_LOW_1.8V VDD_PLL_1.2V AVDD_2.6V VDD_TSP_2.9V VCC_SYN_2.8V AVDD_HFA_2.6V VDD_RX_TX_2.8V VDD_MOT_3.0V +VBUS VDD_CAM_IO_2.8V C301 VDD_IO_HIGH_2.9V C302 C305 C304 C303 C306 C307 VDD_USB_3.3V C308 C310 C309 C311 AUX_ON JACK_IN C300 C312 3PI_L 3PI_R R300 R301 VBAT E11 E9 D8 C1 B2 D2 C11 A 11 A9 A3 E1 C5 A5 A7 B6 D12 MIC_BIAS_2.15V C317 M2 C3 B4 B10 B8 K6 K12 L5 M10 C320 C322 J5 H6 C323 J7 H8 C325 EAR_N C327 K8 L9 SPK_N H12 L11 SPK_P F12 F10 V_EXT_CHARGE OSC300 C9 E5 REF_ON_PMU VCORE_CTRL G9 J9 C318 C319 M4 L3 +VBUS_DETECT C321 H10 RXINN K10 RXINP INA1 INA2 SIMOFFB SIMVCC U302 INB1 INB2 USBLDO VL VBIAS VISA VSAVE C1N C1P OUTN OUTP IRQB SCL SDA LX FB REFBP ONKEYB RESETB XIN XOUT PWREN1 PWREN2 TEST1 TEST2 C326 D10 K4 G1 E3 C328 C330 H4 CLK32K CHGIN CHGINB F4 C7 B12 CLK32K D4 TP300 E7 D6 L1 J3 F8 F6 G5 INT_PMU BAT300 SCL SDA C336 ONKEY_N RSTON L300 VDD_GSM_CORE_1.2V R307 C340 C344 C342 C343 C341 G3 G7 F2 MICBIAS M6 G11 K2 M8 J 11 L7 C335 HPL HPR C339 OSC300 C335 C338 C306 C300 C3 0 5 R3 0 0 C307 C3 2 5 C3 2 3 C344 U3 0 2 C3 2 2 C30 3 C302 C304 C308 C326 C336 C3 1 0 C3 2 1 C3 0 1 C3 3 7 C341 C3 1 7 C343 C318 C3 0 9 C3 2 7 C3 2 0 C3 3 9 C4 2 2 C4 2 6 C34 2 C3 1 1 R307 C330 C3 1 2 R308 R3 0 1 C3 1 9 TA 3 0 0 L3 0 0 C340 R308 C501 C5 0 0 R3 1 5 R3 1 8 C3 5 1 BTC300 C338 2 ZD405 1 H2 J1 SIMOFFn VCC_SIM_3.0V REC1B REC2B 1 2 EAR_P IN1 IN2 IN3 IN4 IN5 IN6 IN7 IN8 IN9 R303 NC NC TA300 A GND GND PGND1 PGND2 PGND3 V SS R305 B A TT B A TTB B A TT S D1VDD D2VDD D3VDD D4VDD D5VDD D6VDD HCVDD IOVDD L CVDD L PVDD RF1VDD RFVDD2 VB US C316 C337 EARSPK_LOUT EARSPK_ROUT R302 MES_BATT 9-7 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization C345 Flow Chart of Troubleshooting 9-1-5. Microphone Part Microphone does not work Yes No Check the connection from MIC Resolder MIC Yes Check the circuit from UCP200 to MIC No Resolder the C403, C406, R401, R409 Yes Check IFC400 PIN 9 = ' H' ? No Check the JACK_IN signal Yes Check the MIC No Replace the MIC Yes END 9-8 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting MIC_BIAS_2.15V ZD400 TA400 R401 C402 L401 C404 C403 C401 MIC_P C405 L421 R402 MIC400 C406 MIC_N R410 C431 R409 ZD402 C430 C400 VDD_IO_HIGH_2.9V FM_ANT VBAT L400 V_EXT_CHARGE D401 R429 IFC400 1 2 3 4 5 6 7 8 9 10 11 12 L416 EARSPK_L EAR_SWITCH JACK_IN TXD1 RXD1 AUX_ON USB_D+_IF USB_D-_IF +VBUS C437 C438 C2 1 3 TP2 0 5 UCP200 C403 C4 3 1 F502 C436 R2 0 5 R4 0 7 F504 C5 0 4 R402 C402 C435 R3 0 3 C4 3 2 C414 C405 C503 C1 1 1 C4 1 5 F5 0 1 C411 R417 R415 C2 0 6 C4 1 2 C2 0 5 R4 2 0 C2 1 5 R4 1 6 F5 0 3 HD C C418 +VBUS_J USB_D-_J USB_D+_J AUX_ON_J RXD1_J TXD1_J TP300 R4 0 1 C406 R409 TA400 R429 C210 R206 C201 C209 C4 1 8 I FC4 0 0 ZD406 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 EARMIC_P EARMIC_N EARSPK_R L415 TP120 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 NC NC NC NC NC NC NC C424 L416 C438 C417 L415 C437 9-9 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-1-6. Speaker Part Speaker does not work Yes No U302 E11 = 3.7V? Resolder or replace U302 Yes No Is there any signal at pin J7(EAR_P) & J8(EAR_N)? Resolder or replace C323, C325 Yes No Is there any signal at pin L11(SPK_P) & H12(SPK_N) ? Resolder or replace U302 Yes No Change the Speaker Is Speaker working? Yes END 9-10 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting VDD_SD_3.3V VDD_IO_LOW_1.8V VDD_PLL_1.2V AVDD_2.6V VDD_TSP_2.9V VCC_SYN_2.8V AVDD_HFA_2.6V VDD_RX_TX_2.8V VDD_MOT_3.0V +VBUS VDD_CAM_IO_2.8V C301 VDD_IO_HIGH_2.9V C303 C302 C306 C305 C304 C307 VDD_USB_3.3V C308 C310 C309 AUX_ON JACK_IN C300 C312 C311 3PI_L 3PI_R R300 R301 VBAT E11 E9 D8 C1 B2 D2 C11 A 11 A9 A3 E1 C5 A5 A7 B6 D12 MIC_BIAS_2.15V C317 M2 C3 B4 B10 B8 K6 K12 L5 M10 C320 C322 IN1 IN2 IN3 IN4 IN5 IN6 IN7 IN8 IN9 J5 H6 J7 H8 C325 EAR_N C327 SPK_N V_EXT_CHARGE OSC300 1 SCL SDA LX FB REFBP ONKEYB RESETB XIN XOUT PWREN1 PWREN2 G9 J9 C335 IRQB TEST1 TEST2 C318 C319 M4 L3 +VBUS_DETECT F2 C321 F4 C7 B12 C326 D10 K4 G1 E3 C328 C330 H4 CLK32K D4 E7 D6 L1 J3 F8 F6 G5 TP300 INT_PMU BAT300 SCL SDA C336 ONKEY_N L300 RSTON VDD_GSM_CORE_1.2V R307 1 2 C340 C344 C341 C342 C343 M6 G11 K2 M8 J 11 L7 C338 VL VBIAS VISA VSAVE CHGIN CHGINB C9 E5 REF_ON_PMU VCORE_CTRL USBLDO CLK32K H2 J1 2 SIMOFFB SIMVCC U302 OUTN OUTP F12 F10 G3 G7 H10 RXINN K10 RXINP C1N C1P H12 L11 SPK_P MICBIAS INB1 INB2 K8 L9 SIMOFFn VCC_SIM_3.0V HPL HPR INA1 INA2 C323 EAR_P R303 REC1B REC2B NC NC TA300 AGND GND PGND1 PGND2 PGND3 VSS R305 B A TT BA TTB BA TTS D1VDD D2VDD D3VDD D4VDD D5VDD D6VDD HCVDD IOVDD L CVDD L PVDD RF1VDD RFVDD2 VB US C316 C337 EARSPK_LOUT EARSPK_ROUT R302 MES_BATT C339 R308 C345 C345 OSC300 C335 C338 C330 C306 C300 C3 0 5 R3 0 0 C307 C3 2 5 C3 2 3 C344 U3 0 2 C3 2 0 C30 3 C302 C304 C308 C326 C336 C3 1 0 C3 0 9 C3 0 1 C3 3 7 C341 C3 1 7 C343 C318 C3 2 1 ZD405 C3 2 7 C3 2 2 C3 3 9 C4 2 2 C4 2 6 C34 2 C3 1 1 R307 C3 1 2 R308 R3 0 1 C3 1 9 TA 3 0 0 L3 0 0 C340 TAC_HOLD C501 C5 0 0 R3 1 8 R3 1 5 BTC300 C3 5 1 SPK400 TP501 TP500 C352 C353 ZD301 HDC503 SPK401 9-11 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-1-7. Receiver Part Receiver does not work Yes No Is there any signal at UCP200 pin E18(RCV_P) & G18(RCV_N) ? Resolder UCP200 or change PBA Yes No Replace the Receiver Is Receiver working? Yes END 9-12 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting VCC_SIM_3.0V VDD_PLL_1.2V HA(18) HA(19) HA(20) HA(21) HA(22) HA(23) K2 C4 HA(0) BE1n HA(1) U3 B1 M2 M3 N2 K5 L4 M4 P1 P3 P8 RXD2 CTS2 INT_PMU BT_INT PON_PA MOT_PWM R9 P18 N1 R1 U2 L5 R3 WAITn CLKBURST RTS2 TXD2 TSP_SCL K4 R8 T9 P9 R12 R13 TSP_INT U17 R11 Y(6) TSP_RST RXD1 Y(7) SD_DETECT CAM_RESET P14 R10 P10 T16 U18 T18 R18 MOD_STANDBY EAR_SWITCH 3PI_DETECT U12 T11 P12 T12 U11 P13 T17 MOT_EN P11 M1 HA(24) TSP_SDA SD_CMD SD_CLK SD_DATA(0) SD_DATA(1) SD_DATA(2) SD_DATA(3) U10 T13 R14 T14 R15 V17 T15 C11 BT_RESET H5 REF_ON RF_RESET HD(0:15) J5 ADC1 ADC2 B7 C7 B6 C6 A6 B5 A5 B4 A4 A3 B3 D6 C3 A2 D4 B2 C1 C2 D2 E5 D3 E3 E1 E4 E2 F4 G3 F3 H4 G4 J4 G5 V3 SIMOFFn R4 P4 R5 U1 T5 T3 T2 T1 R2 M5 R6 P5 N5 T8 P6 LCD_BL_EN CAM_EN R7 T7 VDDVBO T6 D1 C5 D18 V16 J 12 VDDE6 VDDE7 VDDVB VDDREF VDDEPR VDDEPR VDDEPR M9 C13 G12 G11 G10 M11 M12 VDDE4 VDDE5 VDDE6 VDDE2 VDDE3 VDDE2 J7 L7 U9 V13 VDD_CAM_IO_2.8V VDDE1 VDDE1 G9 G8 L 11 VDDE1 G7 G1 B9 U7 C8 K7 VDDE1 VDDE1 VDDE1 VDDE1 VDDE1 VDDD2 VDDD2 VDDCLK H9 M8 L 12 M10 H18 VDDC VDDC VDDC VDDC VDDC VDDCGU E9 E6 H1 U4 A 11 A 15 H7 VDDC VDDC VDDC VDDA2 VDDA3 VDDBB AVDD_HFA_2.6V AVDD_2.6V VDD_SD_3.3V VDD_IO_HIGH_2.9V AUXDAC1 ADC3 AUXDAC2 ADC4 AUXDAC3 ADD0_BE0 AUXMICN BE1 AUXMICP ADD18 MICN ADD19 MICP ADD20 MICBIAS ADD21 ADD22 CAMDATA0 ADD23 CAMDATA1 ADD27 CAMDATA2 GPIOA0 CAMDATA4 GPIOA1 CAMDATA5 CAMDATA3 GPIOA2 CAMDATA6 GPIOA3 CAMDATA7 GPIOA4 CAMCLKI GPIOA5 CAMCLKO GPIOA6 CAMHS GPIOA7 CAMVS GPIOA8 GPIOA9 CS1 GPIOA10 CS3 E18 G18 CS0 GPIOA11 GPIOA13 KCOL0 GPIOA14 KCOL1 GPIOA15 KCOL2 GPIOA16 KCOL3 GPIOA17 KCOL4 GPIOA18 GPIOA19 KROW0 GPIOA20 KROW1 GPIOA21 KROW2 GPIOA22 KROW3 GPIOA23 KROW4 GPIOA24 RFCLK1 GPIOA25 RFDO1 GPIOA26 GPIOA27 RFEN0 GPIOA28 RFSIG0 GPIOA29 RFSIG1 GPIOA30 RFSIG2 GPIOA31 RFSIG6 RFSIG7 GPIOB5 TXDP1 GPIOB9 SIMCLK GPIOB10 SIMIO GPIOB11 SIMPWR GPIOB12 SIMRST GPIOB13 SDA1 SDA2 GPON0 UCP200 VDED0 IO0 VDED1 IO1 VDED2 IO2 VDED3 IO3 VDED4 IO4 VDED5 IO5 VDED6 IO6 VDED7 IO7 VDED8 IO8 VDED9 IO9 VDED10 IO10 VDED11 IO11 VDED12 VDED13 IO12 IO13 VDED14 VDED15 IO14 IO15 IO16 VDEEOF_CLK27M IO17 VDERD IO18 VDEWR IO19 OE_R_W IO20 WE_E IO21 USBDM IO22 IO23 USBDP IO24 USBGNDA IO25 USBID IO26 USBRREF IO27 USBVBUS VDECS1 IO29 IO30 VDECS2 IO31 VDED_C HDP0 IN HDP1 IP HDP2 QN HDP4 QP HDP6 RESET HDP7 RSTBB HDP8 RSTEXT F15 F16 E12 J15 P_CLK M_CLK HSYNC VSYNC J17 G16 E13 N4 CS1n_RAM CS3n_NAND CS0n_FLASH N3 P2 KEY_COL(0:1) KEY_COL(0) KEY_COL(1) P15 N14 M14 N15 L14 KEY_ROW(0:2) KEY_ROW(0) KEY_ROW(1) KEY_ROW(2) K14 K15 M15 J14 L15 J16 RF_CLK RF_DATA RF_EN BAND_SEL M16 K16 R16 R17 P16 P17 VDD_CAM_IO_2.8V VCORE_CTRL PON_3587_SYNTH N16 T10 VDD_IO_LOW_1.8V TXD1 D12 SIM_CLK SIM_IO F17 E14 D11 R202 SIM_RST R203 R204 U401 SCL CAM_SCL SDA CAM_SDA L16 H16 G14 E17 LCDD(0:15) LCDD(0) LCDD(1) LCDD(2) LCDD(3) LCDD(4) LCDD(5) LCDD(6) LCDD(7) LCDD(8) LCDD(9) LCDD(10) LCDD(11) LCDD(12) LCDD(13) LCDD(14) LCDD(15) D13 E11 D14 E15 D17 E16 D15 C17 D16 C18 C15 C16 B18 A17 B17 B16 FLM L_RD L_WR OEn WEn B15 A16 T4 V2 A13 USB_DUSB_D+ A12 B12 B14 C14 R206 C12 +VBUS_DETECT C10 L_CS L_RST L_RS D10 C9 U6 RX_I_N RX_I_P V6 HDP9 TRST RX_Q_N RX_Q_P V5 F2 RSTEXTn RSTON RSTEXTn TRSTn E10 D7 H2 HDP10 HDP11 CLK32I E8 CLK32K HDP12 HDP13 CKITST HDP14 RTCK HDP15 TCK HDP16 TDI TDO HDP17 HFR1 MCLK HFR2 MCLKSEL JSEL VREF FSC EAR1 EAR2 DCL L3 RTCK TCK TDI TDO TMS D_REF_CLK J3 F1 L2 H3 V8 B10 R207 K3 J_SEL C215 V14 B8 PCM_SYNC A10 PCM_CLK PCM_IN PCM_OUT A7 A8 NC NC NC NC VSSVB O VSSVB NC NC VDD_IO_LOW_1.8V D8 2 1 V1 A1 F18 V18 A18 VSSCL K VSSD2 VSSD2 VSSREF VSSA5 VSSBB V7 V4 A9 G2 U14 K18 U15 A14 G NDE G NDE U16 V9 G NDE G NDE U13 G NDE G NDE G NDE G NDE G NDE L9 L8 L10 J 11 K10 GNDE G NDE G NDE G NDE G NDE G NDE J9 E7 H8 D5 J 10 H11 H12 G NDC G NDC P7 G NDC G NDC G NDC G NDC G NDC G NDA2 G NDC J8 L1 K8 K9 K12 D9 H10 K11 DU VSSA4 ANL ANR USB VSSA TERM DD U8 N17 Y(0:5) Y(0) Y(1) Y(2) Y(3) Y(4) Y(5) G17 U5 HDP3 HDP5 USB VSSA REF FM_L FM_R F14 H15 K17 G15 IO28 B13 J18 AUXMIC_N AUXMIC_P MIC_N MIC_P H14 SCL1 SCL2 GPIOC18 H17 N18 RAMP L17 V15 GPIOB8 ADV EAR_P EAR_N V12 L18 GPIOB2 F5 ADVn V11 M17 GPIOA12 TMS RCV_P RCV_N V10 M18 ADD1_BE2 GPON1 HD(0) HD(1) HD(2) HD(3) HD(4) HD(5) HD(6) HD(7) HD(8) HD(9) HD(10) HD(11) HD(12) HD(13) HD(14) HD(15) HA(2) HA(3) HA(4) HA(5) HA(6) HA(7) HA(8) HA(9) HA(10) HA(11) HA(12) HA(13) HA(14) HA(15) HA(16) HA(17) HA(2:17) USB VDDA B 11 HA(18:23) J2 K1 USBVDDADRV J1 MES_BATT VF TEMP_PRODUCT VDD_USB_3.3V VDD_IO_LOW_1.8V VDD_GSM_CORE_1.2V M7 AVDD_2.6V VDDE1 VDD_USB_3.3V 134 C148 104 144 103 R102 TP507 TP506 HD C5 0 1 TP505 TP504 TP202 C2 1 3 TP203 TP120 TP300 TP208 TP2 1 5TP2 1 4TP2 0 9 TP2 0 5 UCP200 UME200 F502 F504 C406 TP204 R4 0 1 TP2 0 0 TP207 C403 C4 3 1 C436 R2 0 5 R402 C402 C2 0 6 C4 3 2 R4 0 7 C5 0 4 C503 R415 R3 0 3 C4 1 5 F5 0 1 C414 C405 C435 C1 1 1 C4 1 2 C2 1 5 R4 2 0 C2 0 5 R4 1 6 F5 0 3 C411 R417 TP212 R409 TP206 TA400 R206 C201 C209 TP201 C210 TP2 1 0 R429 C217 ZD406 IF C4 1 8 C200 C216 R207 C214 R320 R317 TP109 C350 C202 9-13 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-1-8. Headset Part Earphone does not work Yes No Is there any signal at U302 R300, R301? Resolder or replace U302 Yes No Is there any signal at U302 J7, H8 ? Resolder the C323, C325 or Check the UCP200 Yes No IFC400 pin 5,6,7 short? Resolder or replace IFC400 Yes No Is there any signal at IFC400 pin 5, 7 ? Resolder the L415, L416 Yes No Replace the earphone Is Earphone working? Yes END 9-14 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting VDD_SD_3.3V VDD_IO_LOW_1.8V VDD_PLL_1.2V AVDD_2.6V VDD_TSP_2.9V VCC_SYN_2.8V AVDD_HFA_2.6V VDD_RX_TX_2.8V VDD_MOT_3.0V +VBUS VDD_CAM_IO_2.8V C301 VDD_IO_HIGH_2.9V C302 C303 C305 C304 C306 C307 VDD_USB_3.3V C308 C310 C309 C311 AUX_ON JACK_IN C300 C312 3PI_L 3PI_R R300 R301 VBAT EARSPK_LOUT EARSPK_ROUT R302 MIC_BIAS_2.15V E11 E9 D8 C1 B2 D2 C11 A 11 A9 A3 E1 C5 A5 A7 B6 D12 MES_BATT M2 C3 B4 B10 B8 K6 K12 L5 M10 C320 C322 J5 H6 C323 EAR_P J7 H8 C325 EAR_N C327 K8 L9 SPK_N H12 L11 SPK_P F12 F10 V_EXT_CHARGE OSC300 H2 J1 1 C337 2 C338 C9 E5 REF_ON_PMU VCORE_CTRL G9 J9 C318 C319 M4 L3 HPL HPR +VBUS_DETECT F2 MICBIAS C321 H10 RXINN K10 RXINP INA1 INA2 F4 C7 SIMOFFB SIMVCC U302 INB1 INB2 USBLDO VL VBIAS VISA VSAVE C1N C1P OUTN OUTP B12 C326 D10 K4 G1 E3 C328 CLK32K CHGIN CHGINB IRQB XIN XOUT SCL SDA LX FB REFBP ONKEYB RESETB PWREN1 PWREN2 TEST1 TEST2 C330 H4 D4 E7 D6 L1 J3 F8 F6 G5 CLK32K TP300 INT_PMU SDA C336 ONKEY_N RSTON C400 100PF L400 270nH R429 18K IFC400 HY20-AB0310 1 2 3 4 5 6 7 8 9 10 11 12 R308 1005 FM_ANT D401 NC L415 BLM15AG601SN1 1005 L416 BLM15AG601SN1 1005 EARMIC_P EARMIC_N EARSPK_R EARSPK_L EAR_SWITCH JACK_IN TXD1 RXD1 AUX_ON USB_D+_IF USB_D-_IF +VBUS C418 10000nF C437 1NF 1005 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 1005 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 NC NC NC NC NC NC NC 1005 V_EXT_CHARGE C438 1NF VDD_GSM_CORE_1.2V C340 C430 100NF 1005 1005 VDD_IO_HIGH_2.9V L300 R307 C339 VBAT BAT300 SCL C344 C343 C341 C342 SIMOFFn VCC_SIM_3.0V G3 G7 REC1B REC2B IN1 IN2 IN3 IN4 IN5 IN6 IN7 IN8 IN9 M6 G11 K2 M8 J 11 L7 C335 R303 NC NC C317 1 2 TA300 A GND GND PGND1 PGND2 PGND3 VSS R305 B A TT B A TTB B A TTS D1VDD D2VDD D3VDD D4VDD D5VDD D6VDD HCVDD IOVDD L CVDD L PVDD RF1VDD RFVDD2 VB US C316 +VBUS_J USB_D-_J USB_D+_J AUX_ON_J RXD1_J TXD1_J 9-15 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization C345 TP2 1 0 C209 TP201 C217 ZD406 I FC4 0 0 C4 1 8 C200 R207 C214 R320 R317 R316 R309 C348 ZD300 R312 C347 L416 R311 R314 L415 R425 R310 CD 3 0 0 C423 U400 C417 R4 4 0 C349 R4 2 8 C438 TP109 C350 C216 C202 C424 SC100 C201 TP1 1 3 TP204 R206 R2 0 1 R2 0 0 C210 VR2 0 0 TA400 R429 R108 TP110 TP106 2 C110 TP206 1 401 C406 R409 TP1 0 8 Flow Chart of Troubleshooting C437 R3 1 3 L4 0 6 L4 0 7 C4 2 1 R2 0 2 R2 0 3 R2 0 4 U4 0 1 C328 C345 OSC300 C335 C338 C330 C306 C3 0 5 C307 C3 2 5 C3 2 3 C344 U3 0 2 C3 2 0 C336 C3 1 0 SIM300 ZD405 This Document can not be used without Samsung's authorization C326 C3 2 1 SAMSUNG Proprietary-Contents may change without notice C304 C308 C3 0 1 9-16 C302 C3 3 7 C341 C3 1 7 C4 2 2 C343 C318 C30 3 C3 0 9 C3 2 7 C4 2 6 C34 2 C300 C3 1 1 R307 C3 1 2 R308 C3 2 2 ZD503 C3 3 9 L402 R3 0 0 C413 C340 R3 0 1 C410 C3 1 9 TA 3 0 0 R421 L3 0 0 Z D404 Z D4 03 L422 TAC_DN Flow Chart of Troubleshooting 9-1-9. Camera Part (Mega and VGA) Camera function does not work Check camera FPCB and connector NO Re-connect the camera FPCB YES HDC503 C501 = 2.8V NO Check the U302 NO Check HDC503(pin12, 14) if YES HDC503 pin 12, 14 = 26MHz? operating at 26MHz and UCP200 YES Replace the New Camera & END 9-17 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting VDD_CAM_IO_2.8V VCAM_A_2.8V VCAM_CORE_1.5V 1 3 5 7 9 11 13 15 17 19 21 23 Y(1) Y(3) Y(5) Y(7) VSYNC HSYNC TP500 TP501 1 3 5 7 9 11 13 15 17 19 21 23 2 4 6 8 10 12 14 16 18 20 22 24 2 4 6 8 10 12 14 16 18 20 22 24 Y(0) Y(2) Y(4) Y(6) P_CLK M_CLK R501 R502 TP503 HDC503 C500 C501 C502 C509 9-18 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization CAM_SDA CAM_SCL CAM_RESET Flow Chart of Troubleshooting TP1 0 4 TP1 1 1 TP208 TP1 0 7 TP2 1 5TP2 1 4TP2 0 9 F100 U100 UCP200 TP2 0 0 TP207 TP204 TP1 0 8 TP1 1 3 R2 0 1 R2 0 0 TP2 1 0 L1 0 5 R108 TP110 TP106 VR2 0 0 TP201 C200 R207 C214 R320 R317 SC100 C217 TP109 C350 C216 C202 R316 R309 C348 ZD300 R312 C347 R311 R314 R310 CD 3 0 0 R4 4 0 R4 2 8 C349 C125 C1 1 2 TP206 C1 2 1 C115 C110 C209 13 C124 C1 0 7 C201 C117 C106 R1 0 5 R206 00 1 C1 0 9 C210 07 08 TP2 0 5 UME200 L104 L107 C423 R425 U400 L4 0 6 R3 1 3 C4 2 1 L4 0 7 R2 0 2 R2 0 3 R2 0 4 U4 0 1 C328 C345 OSC300 C335 C338 C330 C306 C300 C3 0 5 C307 R3 0 1 C3 2 5 C3 2 3 C344 U3 0 2 C3 2 0 C30 3 C302 C304 C308 C326 C336 C3 1 0 C3 2 1 C3 0 1 C3 3 7 C341 C3 1 7 C343 C318 C3 0 9 SIM300 ZD405 C3 2 7 C3 2 2 C3 3 9 C4 2 2 C4 2 6 C34 2 C3 1 1 R307 C3 1 2 R308 R3 0 0 C3 1 9 TA3 0 0 L3 0 0 C340 TAC_HOLD C501 C5 0 0 R3 1 5 R3 1 8 BTC300 TP501 TP500 C352 T4 00 C353 SPK401 HDC503 MO C3 5 1 SPK400 ZD301 TP503 9-19 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-2. RF ** When testing TX chain, check ALL RF devices, resistors, inductors, and capacitors. 9-2-1. GSM850/GSM900 Transmitter TX ON: Level 5 U103 pin31 ≥ NO Check OSC100 2.65V Check Antenna Switch Control YES PAM100 pin2 NO Check PAM100 PIN8=H, PIN9=L ≥ -15dBm PIN10=H YES U103 PIN15 YES NO Re-solder or Change Re-solder R103, C144 ≥ -15dBm YES Check U103, PAM100 END 9-20 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization PAM100 Flow Chart of Troubleshooting 1 2 3 4 C A G G RFS100 L100 ANT101 ANT103 C100 L116 L102 L109 C101 C147 15 14 VBAT A NT GND NC 16 GND 20 L121 GND C105 LB_RX NC GND NC GND GND GND GND 22 11 TP100 TP101 GPCTRL1 10 GPCTRL0 9 PAM100 TX_EN VRAMP 2 MOD_STANDBY BAND_SEL C104 TP102 8 PON_PA R104 RAMP 7 GND 24 GND 23 GND 21 RFIN_L B RFIN_HB 19 13 12 6 5 3 1 VBATT C134 4 HB_RX RX1 17 RX0 18 C103 HB_TX LB_TX L101 L108 F101 L103 HB_RX L118 1 IN 6 7 8 9 C120 G G G G G L120 GSM1800_OUT GSM1800_OUT GSM1900_OUT GSM1900_OUT 2 3 4 5 10 L110 C123 L112 F102 C128 6 7 8 9 L111 G G G G G L114 17 VDD XTAL2 VDD XTAL1 VIO XEN _RESET 8 X OUT 7 B IP 6 B IN 4 B QN 36 _PDN 5 B QP NC 3 SDIO NC 1 SCL K GND 16 15 14 VDD_IO_LOW_1.8V VDD_RX_TX_2.8V C130 TP120 RF_RESET PON_3587_SYNTH OSC100 BT_CLK C111 RF_CLK LB_TX 13 GND U103 VDD C144 12 VDD HB_TX R103 11 RFOL C148 R102 10 RFOH 9 AFC RFIPP 19 20 18 RFIPN RFIDP 21 RFIEP RFIDN 22 RFIEN RFIA P XDIV 2 _SEN 25 26 27 28 29 30 31 35 3 4 3 3 32 2 3 4 XMODE NC REF_ON_PMU VCC_SYN_2.8V RFIA N 24 23 L115 1 L113 GSM850_OUT GSM850_OUT GSM900_OUT GSM900_OUT 2 3 4 5 10 1 IN LB_RX D_REF_CLK RF_EN RF_DATA RX_I_P RX_I_N RX_Q_P RX_Q_N 9-21 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting F1 0 2 PAM1 0 0 F1 0 1 L1 2 1 R1 0 4 C148 TP212 TP203 TP1 1 2 TP120 TP300 R2 0 8 TP1 0 7 TP1 1 1 TP208 TP2 1 5TP2 1 4TP2 0 9 TP105 UCP200 This Document can not be used without Samsung's authorization R1 0 1 SAMSUNG Proprietary-Contents may change without notice R1 0 5 9-22 C1 0 9 C402 R1 0 7 C1 0 8 TP2 0 5 UME200 U100 C2 1 3 R2 0 5 R402 R3 0 3 C405 C4 3 2 C414 L120 R102 C2 0 6 C4 1 5 C1 1 1 C4 1 2 C2 1 5 R4 2 0 C2 0 5 R4 1 6 C411 R417 TP100 C1 3 4 C1 4 4 R1 0 3 C130 TP1 0 1 C120 L1 1 8 L1 1 0 C122 TP202 OSC1 0 0 L101 C1 0 4 C1 0 3 L1 0 8 L103 TP102 L111 RFS100 L115 C105 C123 L1 1 3 C128 L1 1 4 U103 L1 1 2 C133 Flow Chart of Troubleshooting 9-2-2. DCS1800/PCS1900 Transmitter TX ON: Level 0 U103 PIN31 ≥ NO Check OSC100 2.65V Check Antenna YES Switch Control PAM100 PIN2 NO Check PAM100 PIN8=H, PIN9=H ≥ -15dBm PIN10=H YES YES Re-solder or Change PAM100 NO U103 PIN16 Re-solder R102, ≥ -15dBm C148 YES Check U103, PAM100 END 9-23 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 1 2 3 4 C A G G RFS100 L100 ANT101 ANT103 C100 L116 L102 L109 C101 C147 14 15 A NT VBAT GND NC 16 GND 20 L121 GND C105 LB_RX RX1 17 RX0 18 C103 VBATT 11 TP100 TP101 GPCTRL1 10 GPCTRL0 9 PAM100 TX_EN MOD_STANDBY BAND_SEL C104 TP102 8 PON_PA R104 RAMP VRAMP 7 GND 24 GND 23 GND 21 2 RFIN_L B RFIN_HB 19 13 12 6 5 3 1 NC GND NC GND GND GND GND C134 4 HB_RX 22 HB_TX LB_TX L101 L108 F101 L103 HB_RX L118 1 IN 6 7 8 9 C120 G G G G G L120 GSM1800_OUT GSM1800_OUT GSM1900_OUT GSM1900_OUT 2 3 4 5 10 L110 C123 L112 F102 C128 L111 L114 18 17 RFIPP VDD XTAL2 VDD XTAL1 VIO XEN _RESET 8 XOUT 6 B IN 7 B IP _PDN 5 B QP 4 B QN 36 NC 2 _SEN NC 3 SDIO GND 14 VDD_IO_LOW_1.8V VDD_RX_TX_2.8V C130 TP120 RF_RESET PON_3587_SYNTH OSC100 BT_CLK C111 RF_CLK LB_TX 15 16 C144 13 GND U103 VDD HB_TX R103 12 VDD C148 R102 11 RFOL 10 RFOH 9 RFIPN 20 19 RFIDP RFIDN 22 21 RFIEN RFIEP RFIA P RFIA N XDIV AFC 1 SCL K 25 26 27 28 29 30 31 35 3 4 3 3 32 2 3 4 XMODE NC REF_ON_PMU VCC_SYN_2.8V 23 24 L115 1 L113 GSM850_OUT GSM850_OUT GSM900_OUT GSM900_OUT G G G G G LB_RX 6 7 8 9 2 3 4 5 10 1 IN D_REF_CLK RF_EN RF_DATA RX_I_P RX_I_N RX_Q_P RX_Q_N 9-24 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting PAM1 0 0 TP203 TP1 1 2 TP120 TP300 R2 0 8 T P1 0 7 TP1 1 1 TP208 TP2 1 5TP2 1 4TP2 0 9 TP105 UCP200 This Document can not be used without Samsung's authorization R1 0 1 SAMSUNG Proprietary-Contents may change without notice R1 0 5 9-25 C1 0 9 C402 R1 0 7 C1 0 8 TP2 0 5 UME200 U100 R2 0 5 TP212 TP202 OSC1 0 0 F1 0 2 F1 0 1 L1 2 1 C1 3 4 C148 C2 1 3 R3 0 3 R402 C4 3 2 C405 L120 R102 C2 0 6 C1 1 1 C4 1 5 C414 TP100 R1 0 4 C1 4 4 R1 0 3 C4 1 2 C2 1 5 R4 2 0 C2 0 5 R4 1 6 C411 R417 TP1 0 1 C120 C130 C1 0 4 L101 L1 1 8 L1 1 0 C122 C1 0 3 L1 0 8 L103 TP102 L111 RFS100 L115 C105 C123 L1 1 3 C128 L1 1 4 U103 L1 1 2 C133 Flow Chart of Troubleshooting 9-2-3. GSM850 Receiver RX ON AMP-50dBm PAM100 PIN15 NO ≥ -55dBm Resolder RFS100, L116, L121 Check Antenna Switch Control YES PAM100 PIN17 NO Check PAM100 PIN8=L, PIN9=H ≥ -70dBm PIN10=H Resolder or Change YES YES NO F102 PIN1 ≥ -70dBm PAM100 Resolder or change C105 Resolder or change F102 YES U103 PIN23,24 ≥ -75dBm NO Check F102 PIN6, PIN7 ≥ -75dBm YES YES Check U103, Resolder or change C123, C128, L112 PAM100 END 9-26 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 1 2 3 4 C A G G RFS100 L100 ANT101 ANT103 C100 L116 L102 L109 C101 C147 15 14 VBAT A NT GND NC 16 GND 20 L121 GND C105 LB_RX RX1 17 RX0 18 C103 VBATT 11 TP100 TP101 GPCTRL1 10 GPCTRL0 9 PAM100 TX_EN VRAMP 2 MOD_STANDBY BAND_SEL C104 TP102 8 PON_PA R104 RAMP 7 GND 24 GND 23 GND 21 RFIN_L B RFIN_HB 19 13 12 6 5 3 1 NC GND NC GND GND GND GND C134 4 HB_RX 22 HB_TX LB_TX L101 L108 F101 L103 HB_RX L118 1 IN 6 7 8 9 C120 G G G G G L120 GSM1800_OUT GSM1800_OUT GSM1900_OUT GSM1900_OUT 2 3 4 5 10 L110 C123 L112 F102 C128 L111 L114 17 RFIPP VDD VDD XTAL2 VDD XTAL1 VIO XEN _RESET 8 XOUT 6 BIN 7 BIP _PDN 5 B QP 36 4 B QN NC 3 SDIO NC 2 _ SEN GND 14 VDD_IO_LOW_1.8V VDD_RX_TX_2.8V C130 TP120 RF_RESET PON_3587_SYNTH OSC100 BT_CLK C111 RF_CLK LB_TX 15 16 C144 13 GND U103 HB_TX R103 12 VDD C148 R102 11 RFOL 10 RFOH 9 19 RFIDP RFIPN 21 22 23 24 20 RFIDN RFIEP RFIEN RFIA P RFIA N XDIV AFC 1 SCL K 25 26 27 28 29 30 31 35 34 3 3 32 2 3 4 XMODE NC REF_ON_PMU VCC_SYN_2.8V 18 L115 1 L113 GSM850_OUT GSM850_OUT GSM900_OUT GSM900_OUT G G G G G LB_RX 6 7 8 9 2 3 4 5 10 1 IN D_REF_CLK RF_EN RF_DATA RX_I_P RX_I_N RX_Q_P RX_Q_N 9-27 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting PAM1 0 0 L120 C148 TP203 TP1 1 2 07 TP1 1 1 TP105 TP300 TP208 1 5TP2 1 4TP2 0 9 R1 0 0 C1 1 3 R1 0 1 C1 0 9 This Document can not be used without Samsung's authorization R1 0 7 C1 0 8 SAMSUNG Proprietary-Contents may change without notice TP1 0 4 TP120 R2 0 8 TP2 0 5 C4 3 2 9-28 L106 L107 C117 C124 U100 R2 0 5 C2 1 3 R3 0 3 C2 0 6 C1 1 1 TP212 B A T3 0 0 R102 TP202 OSC1 0 0 F1 0 2 F1 0 1 L1 0 0 L1 1 6 C1 4 7 R1 0 4 L1 2 1 TP100 C1 3 4 C1 4 4 C4 1 5 C2 0 5 R4 2 0 C4 1 2 R417 C2 1 5 R4 1 6 C411 C414 R1 0 3 C130 TP1 0 1 C120 C1 0 4 L101 L1 1 8 L1 1 0 C122 C1 0 3 L1 0 8 L103 TP102 L111 RFS100 L115 C105 C123 L1 1 3 C128 L1 1 4 U103 L1 1 2 C133 Flow Chart of Troubleshooting 9-2-4. GSM900 Receiver RX ON AMP-50dBm PAM100 PIN15 NO ≥ -55dBm Resolder RFS100, L116, L121 Check Antenna Switch Control YES PAM100 PIN17 NO Check PAM100 PIN8=L, PIN9=H ≥ -70dBm PIN10=H YES F102 PIN1 YES NO Resolder or Change PAM100 Resolder or change C105 ≥ -70dBm Resolder or change F102 YES U103 PIN21,22 ≥ -75dBm NO Check F102 PIN8, PIN9 ≥ -75dBm YES YES Check U103, PAM100 END 9-29 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Resolder or change L111, L114, L115 Flow Chart of Troubleshooting 1 2 3 4 C A G G RFS100 L100 ANT101 ANT103 C100 L116 L102 L109 C101 C147 15 14 VBAT A NT GND NC 16 GND 20 L121 GND C105 LB_RX NC GND NC GND GND GND GND 22 11 TP100 TP101 GPCTRL1 10 GPCTRL0 9 PAM100 TX_EN VRAMP 2 MOD_STANDBY BAND_SEL C104 TP102 8 PON_PA R104 RAMP 7 GND 24 GND 23 GND 21 RFIN_L B RFIN_HB 19 13 12 6 5 3 1 VBATT C134 4 HB_RX RX1 17 RX0 18 C103 HB_TX LB_TX L101 L108 F101 L103 HB_RX L118 1 IN 6 7 8 9 C120 G G G G G L120 GSM1800_OUT GSM1800_OUT GSM1900_OUT GSM1900_OUT 2 3 4 5 10 L110 C123 L112 F102 C128 6 7 8 9 L111 G G G G G L114 17 RFIPP VDD XTAL2 VDD XTAL1 VIO XEN _RESET 8 X OU T 6 B IN 7 B IP _PDN 5 B QP 36 3 SDIO NC 4 B QN NC 2 _SEN GND 16 15 14 VDD_IO_LOW_1.8V VDD_RX_TX_2.8V C130 TP120 RF_RESET PON_3587_SYNTH OSC100 BT_CLK C111 RF_CLK LB_TX 13 GND U103 VDD C144 12 VDD HB_TX R103 11 RFOL C148 R102 10 RFOH 9 19 18 RFIPN 20 RFIDN RFIDP 22 21 RFIEN RFIEP RFIA P RFIA N XDIV AFC 1 SCL K 25 26 27 28 29 30 31 35 34 33 32 2 3 4 XMODE NC REF_ON_PMU VCC_SYN_2.8V 23 24 L115 1 L113 GSM850_OUT GSM850_OUT GSM900_OUT GSM900_OUT 2 3 4 5 10 1 IN LB_RX D_REF_CLK RF_EN RF_DATA RX_I_P RX_I_N RX_Q_P RX_Q_N 9-30 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting PAM1 0 0 L120 C148 TP203 TP1 1 2 07 TP1 1 1 TP105 TP300 TP208 1 5TP2 1 4TP2 0 9 C1 1 3 R1 0 0 R1 0 1 C1 0 9 This Document can not be used without Samsung's authorization R1 0 7 C1 0 8 SAMSUNG Proprietary-Contents may change without notice TP1 0 4 TP120 R2 0 8 TP2 0 5 C4 3 2 9-31 L106 L107 C117 C124 U100 C2 1 3 R2 0 5 R3 0 3 C2 0 6 C1 1 1 TP212 B A T3 0 0 R102 TP202 OSC1 0 0 F1 0 2 F1 0 1 L1 0 0 L1 1 6 C1 4 7 R1 0 4 L1 2 1 TP100 C1 3 4 C1 4 4 C4 1 5 C2 1 5 R4 2 0 C4 1 2 C414 C2 0 5 R4 1 6 C411 R417 R1 0 3 C130 TP1 0 1 C120 C1 0 4 L101 L1 1 8 L1 1 0 C122 C1 0 3 L1 0 8 L103 TP102 L111 RFS100 L115 C105 C123 L1 1 3 C128 L1 1 4 U103 L1 1 2 C133 Flow Chart of Troubleshooting 9-2-5. DCS1800 Receiver RX ON AMP-50dBm PAM100 PIN15 NO ≥ -55dBm Resolder RFS100, L116, L121 Check Antenna Switch Control YES PAM100 PIN18 NO Check PAM100 PIN8=L, PIN9=L ≥ -70dBm PIN10=H YES YES NO F101 PIN1 Resolder or Change PAM100 Resolder or change C103, L118 ≥ -70dBm Resolder or change F102 YES U103 PIN19,20 ≥ -75dBm NO Check F101 PIN6, PIN7 ≥ -75dBm YES YES Resolder or change L101, L103, L108 Check U103, PAM100 END 9-32 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 1 2 3 4 C A G G RFS100 L100 ANT101 ANT103 C100 L116 L102 L109 C101 C147 15 14 VBAT A NT GND NC 16 GND 20 L121 GND C105 LB_RX RX1 17 RX0 18 C103 NC GND NC GND GND GND GND PAM100 TX_EN VRAMP 22 11 TP100 TP101 2 MOD_STANDBY BAND_SEL C104 TP102 8 PON_PA R104 RAMP 7 GND 24 GND 23 GND 21 RFIN_L B RFIN_HB 19 13 12 6 5 3 1 VBATT GPCTRL1 10 GPCTRL0 9 C134 4 HB_RX HB_TX LB_TX L101 L108 F101 L103 HB_RX L118 1 IN 6 7 8 9 C120 G G G G G L120 GSM1800_OUT GSM1800_OUT GSM1900_OUT GSM1900_OUT 2 3 4 5 10 L110 C123 L112 F102 C128 L111 L114 17 VDD VDD XTAL2 VDD XTAL1 VIO XEN _RESET 8 XOUT 7 B IP 6 B IN _PDN 5 B QP 36 3 SDIO NC 4 B QN NC 2 _SEN GND VDD_RX_TX_2.8V C130 TP120 16 BT_CLK C111 D_REF_CLK RF_EN RF_DATA RF_RESET PON_3587_SYNTH OSC100 RF_CLK LB_TX 15 14 VDD_IO_LOW_1.8V 13 GND U103 C144 12 VDD HB_TX R103 11 RFOL C148 R102 10 RFOH 9 AFC RFIPP 19 20 18 RFIPN RFIDP 21 RFIDN RFIEP 22 RFIEN RFIA P XDIV 1 SCL K 25 26 27 28 29 30 31 35 34 33 32 2 3 4 XMODE NC REF_ON_PMU VCC_SYN_2.8V RFIA N 24 23 L115 1 L113 GSM850_OUT GSM850_OUT GSM900_OUT GSM900_OUT G G G G G LB_RX 6 7 8 9 2 3 4 5 10 1 IN RX_I_P RX_I_N RX_Q_P RX_Q_N 9-33 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting F1 0 2 PAM1 0 0 F1 0 1 L1 2 1 C1 3 4 C148 TP212 TP203 TP1 1 2 TP120 TP300 R2 0 8 TP1 0 7 TP1 1 1 TP208 TP2 1 5TP2 1 4TP2 0 9 TP105 UCP200 This Document can not be used without Samsung's authorization R1 0 1 SAMSUNG Proprietary-Contents may change without notice R1 0 5 9-34 C1 0 9 C402 R1 0 7 C1 0 8 TP2 0 5 UME200 U100 C2 1 3 R2 0 5 R402 R3 0 3 C405 C4 3 2 C414 L120 R102 C2 0 6 C4 1 5 C1 1 1 C4 1 2 C2 1 5 R4 2 0 C2 0 5 R4 1 6 C411 R417 TP100 R1 0 4 R1 0 3 C1 4 4 C130 TP1 0 1 C120 L1 1 8 L1 1 0 C122 TP202 OSC1 0 0 L101 C1 0 4 C1 0 3 L1 0 8 L103 TP102 L111 RFS100 L115 C105 C123 L1 1 3 C128 L1 1 4 U103 L1 1 2 C133 Flow Chart of Troubleshooting 9-2-6. PCS1900 Receiver RX ON AMP-50dBm PAM100 PIN15 NO ≥ -55dBm Resolder RFS100, L116, L121 Check Antenna Switch Control YES PAM100 PIN18 NO Check PAM100 PIN8=L, PIN9=L ≥ -70dBm PIN10=H YES YES NO F101 PIN1 Resolder or Change PAM100 Resolder or change C103, L118 ≥ -70dBm Resolder or change F102 YES U103 PIN17,18 ≥ -75dBm NO Check F101 PIN8, PIN9 ≥ -75dBm YES YES Resolder or change C120, C122, L110 Check U103, PAM100 END 9-35 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 1 2 3 4 C A G G RFS100 L100 ANT101 ANT103 C100 L116 L102 L109 C101 C147 15 14 VBAT A NT GND NC 16 GND 20 L121 GND C105 LB_RX RX1 17 RX0 18 C103 VBATT 11 TP100 TP101 GPCTRL1 10 GPCTRL0 9 PAM100 TX_EN VRAMP 2 MOD_STANDBY BAND_SEL C104 TP102 8 PON_PA R104 RAMP 7 GND 24 GND 23 GND 21 RFIN_L B RFIN_HB 19 13 12 6 5 3 1 NC GND NC GND GND GND GND C134 4 HB_RX 22 HB_TX LB_TX L101 L108 F101 L103 HB_RX L118 1 IN 6 7 8 9 C120 G G G G G L120 GSM1800_OUT GSM1800_OUT GSM1900_OUT GSM1900_OUT 2 3 4 5 10 L110 C122 C123 L112 F102 C128 6 7 8 9 L111 G G G G G L114 17 RFIPP VDD XTAL2 VDD XTAL1 VIO XEN _RESET 8 XOUT 7 B IP 6 B IN _PDN 5 B QP 36 4 B QN NC 3 SDIO NC 2 _SEN GND 16 15 14 VDD_IO_LOW_1.8V VDD_RX_TX_2.8V C130 TP120 BT_CLK C111 D_REF_CLK RF_EN RF_DATA RF_RESET PON_3587_SYNTH OSC100 RF_CLK LB_TX 13 GND U103 VDD C144 12 VDD HB_TX R103 11 RFOL C148 R102 10 RFOH 9 19 20 21 18 RFIPN RFIDP RFIDN RFIEP 22 RFIEN RFIA P XDIV AFC 1 SCL K 25 26 27 28 29 30 31 35 34 33 32 2 3 4 XMODE NC REF_ON_PMU VCC_SYN_2.8V RFIA N 24 23 L115 1 L113 GSM850_OUT GSM850_OUT GSM900_OUT GSM900_OUT 2 3 4 5 10 1 IN LB_RX RX_I_P RX_I_N RX_Q_P RX_Q_N 9-36 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting PAM1 0 0 TP203 TP1 1 2 TP120 TP300 R2 0 8 TP1 0 7 TP1 1 1 TP208 TP2 1 5TP2 1 4TP2 0 9 TP105 UCP200 This Document can not be used without Samsung's authorization R1 0 1 SAMSUNG Proprietary-Contents may change without notice R1 0 5 9-37 C1 0 9 C402 R1 0 7 C1 0 8 TP2 0 5 UME200 U100 TP212 TP202 OSC1 0 0 F1 0 2 F1 0 1 L1 2 1 C1 3 4 C148 C2 1 3 R2 0 5 R402 R3 0 3 C405 C4 3 2 C414 L120 R102 C2 0 6 C4 1 5 C1 1 1 C4 1 2 C2 1 5 R4 2 0 C2 0 5 R4 1 6 C411 R417 TP100 R1 0 4 C1 4 4 R1 0 3 C130 TP1 0 1 C120 C1 0 4 L101 L1 1 8 L1 1 0 C122 C1 0 3 L1 0 8 L103 TP102 L111 RFS100 L115 C105 C123 L1 1 3 C128 L1 1 4 U103 L1 1 2 C133 7. Block Diagrams 7-1 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Block Diagrams Y]to¡ j 7-2 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Block Diagrams OZYo¡P OY]to¡P 7-3 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization 8. PCB Diagrams 8-1. Top 8-1 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization PCB Diagrams 8-2. Bottom 8-2 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization