Download Hunter 35180 User's Manual
Transcript
Add salt only by the pinch, since too much salt can cause excessive boiling or blowing of fuse. If the vaporizer has been operating normally and is now failing to steam, it needs to be cleaned. maain inttenan ce section. See the weekl y m u s e bbll ows : B. Vap or iz er oop p er ate s tto o o ffaast , ffu Overboiling, flickering lights, blown fuse or heavy steam flow generally indicates one of the following causes: 1. Too much salt was added to the water. To correct the condition: Disconnect the vaporizer from the electrical outlet and allow to cool. Pour out the water and rinse the ToteAwayTM tank. Rinse steam unit as described in the weekly maintenance section. Refill with fresh water but do not add salt. If vaporizer now does not operate or steams too slowly, follow instructions in above section A. 2. You live in a “hard water” area and minerals in the tap water are causing the vaporizer to steam too rapidly. To correct the condition: Disconnect the vaporizer from the electrical outlet and allow to cool. Remove steam unit allowing hot water to first dribble out, then pour out water and rinse the ToteAwayTM tank. Rinse steam unit as described in the weekly maintenance section. Refill with fresh water but do not add salt. If unit still steams too rapidly, use 1/2 distilled water and 1/2 tap water. Food and drug stores usually stock distilled water. In “hard water” areas it is advisable to clean the unit every few days in accordance with the w e ek ly m maa in intten an ce instructions. d s oorr w o nt ain ot : u z z in in o un C . Vap or iz er iiss m ineer iiss unu unuss uallllyy hho maakin ingg ccrr acklin lingg / bbu ingg / humm hummin ingg sso und waater cco 1. You may have added too much salt. See section B above. 2. You may live in a “hard water” area. See section B above. 3. This condition can happen when the water level in the the ToteAwayTM tank is low. Disconnect the vaporizer from the electrical outlet, allow to cool, remove steam unit allowing hot water to first dribble out. Fill the ToteAwayTM tank with tap water to MAX water level marking. 4. This may be an indication your vaporizer needs cleaning. Refer to the we ek ly m maain inttenan ce section. ur C u stom er SSeer vi ce If yyo ou aarre ssttill ex p eri en cin p er atin o ur vvaa p or iz er, p pll eas e ccaall oour Cu exp ingg di difff i cul ultt y oop ingg yyo D epar tmen t aatt 1-888-830-1326. 3. service parts To obtain a service part for your vaporizer, call customer service at 1-888-830-1326 or e-mail us at [email protected]. Please be prepared to tell the operator the model number of your vaporizer and the name of the part you need to replace and the part number. Servicable Parts: Removable Medicine Cup 94798-00-000 Power Cord 94797-00-000 41651-01 7/21/2003 © 2003 Hunter Fan Company Hunter Fan Company 2500 Frisco Avenue Memphis, Tennessee 38114 warranty Hun o mp untter FFaan C Co mpaany lu The C luss Caare FFrree ® V Vaap or iz er PPlu 3Y Yeear Lim Limii te d W Waar r an t y The Hunter Fan Company, Inc. makes the following warranty to the original residential user or consumer purchaser of The Care Free® Vaporizer Plus: If any part of The Care Free® Vaporizer Plus ("Vaporizer") fails during the first 3 (three) years from the date of purchase due to a defect in material or workmanship, we will provide a replacement part free of charge. If no replacement part can be provided, we will replace your Vaporizer. IF THE ORIGINAL RESIDENTIAL USER OR CONSUMER PURCHASER CEASES TO OWN THE VAPORIZER, THIS WARRANTY AND ANY IMPLIED WARRANTY WHICH THEN REMAINS IN EFFECT, INCLUDING BUT NOT LIMITED TO ANY IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE, ARE VOIDED. THIS WARRANTY IS IN LIEU OF ALL OTHER EXPRESS WARRANTIES. THE DURATION OF ANY IMPLIED WARRANTY, INCLUDING BUT NOT LIMITED TO ANY IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE IS EXPRESSLY LIMITED TO THE PERIOD OF THE EXPRESS WARRANTY SET FORTH ABOVE. This warranty is voided if your Vaporizer is not purchased and used in the USA or Canada. This warranty excludes and does not cover defects, malfunctions, or failures of the Vaporizer which were caused by repairs by persons not authorized by us, use of parts, or accessories not authorized by us, mishandling, modifications, or damage to the Vaporizer while in your possession, or unreasonable use, including failure to provide reasonable and necessary maintenance. This warranty does not cover Vaporizers used in commercial applications. There are no express or implied warranties as to commercial purchasers or users. To obtain service, contact the nearest Hunter authorized service center or the Hunter Fan Company Service Department, 2500 Frisco Avenue, Memphis, Tennessee 38114, 901-248-2222. You will be responsible for insurance and freight or other transportation to our factory service center. We will return the Vaporizer freight prepaid to you. The Vaporizer should be properly packaged to avoid damage in transit since we will not be responsible for any such damage. Proof of purchase is required when requesting warranty service. The purchaser must present the sales receipt or other document that establishes proof of purchase. IN NO EVENT SHALL HUNTER FAN COMPANY BE LIABLE FOR DIRECT, INDIRECT, SPECIAL, CONSEQUENTIAL OR INCIDENTAL DAMAGES IN EXCESS OF THE PURCHASE PRICE OF THE VAPORIZER. YOUR SOLE REMEDY WILL BE REPAIR OR REPLACEMENT AS PROVIDED ABOVE. SOME AMERICAN STATES AND CANADIAN PROVINCES DO NOT ALLOW • LIMITATIONS ON HOW LONG AN IMPLIED WARRANTY LASTS; • THE EXCLUSION OR LIMITATION OF DIRECT, INDIRECT, SPECIAL, INCIDENTAL OR CONSEQUENTIAL DAMAGES; • THE EXCLUSION OR INVALIDITY OF EXPRESS OR IMPLIED WARRANTIES IF THE USER CEASES TO OWN THE VAPORIZER; • THE LIMITATION OF THE REMEDIES AND RECOURSES AVAILABLE TO THE PURCHASER; OR • THE INVALIDITY OF AN EXPRESS WARRANTY WHEN A PRODUCT IDENTIFIED BY BRAND NAME IS NOT USED (UNLESS SPECIFIC CONDITIONS ARE FULFILLED); SO THE ABOVE LIMITATIONS OR EXCLUSIONS MAY NOT APPLY TO YOU. THIS WARRANTY GIVES YOU SPECIFIC LEGAL RIGHTS AND YOU MAY ALSO HAVE OTHER RIGHTS WHICH VARY FROM STATE TO STATE OR PROVINCE TO PROVINCE. Model 35180 Fea tur es: eatur tures: 2-in-1 Easy Lock Feature Vari-Mist Selector Removable Medicine Cup ToteAway Tank Easy Drain Plug NiteGlo Power Light TM TM TM TM TM warnings R E AD A N D SSA AVE T HE SE IIN NST RUCT AN TH CTIIO NS h is vvaap o r iz er oon n ot w ork p n aan n un ur • Thi s vvaap o r iz er m prrop er ly oon unee ven ssur urff ace. A ALLWAYS p plla ce tth maay n no wo a ffir ir m , llee vel, aan nd w ur he vvaa p or iz er aatt lleea st si irm waater rreesi sisst ant ssur urfface . A ALLWAYS p pll ace tth sixx (6) in incche s aw ay ffrro m w n d hheeat sso o ur uch aass sstto v es , rraadi waallllss aan urcces ssu diaato r s , oorr hheeaters . o n iiss h ilild d ren . SSup up hat iiss oou ut ooff tth h e rreea ch ooff cch n aarrea tth h e vvaap o ri zer in aan • ALWAYS p sio upeer v isi pll ace tth d s oorr p d ren, in hilild he vvaap or iz er iiss uuss ed n h en tth re co mm peet s . invvalilid neea r cch wh mmeen d e d w ON OT uuss e or aan ny si o rd aan n d in h e cco sin h e vvaap o r iz er, ex • B e fore uusin NO DO siggn s ooff ddaamage . D inssp ec t ffo extten d tth singg tth th e p he cco ord hhaas bbeeen ddaamaged. prro du ducc t iiff tth • Thi s p o l ar iz ed p lu n e bblla d e iiss w ha n tth he ootth er) aass a ssaafet y ffeeatur hi s prro du ducc t hhaa s a p po plu lugg (o (on wii d er tth uree . T Th plu ill ffii t in o l ar iz ed oou utl et oonl nl ne w he p lu o es n o t ffii t ffull ull h e oou utl et , lugg w will intto a p po nlyy oon waay. IIff tth plu lugg ddo no ullyy in intto tth rev er s e tth he p lu oes n o t ffiit , cco o nt ac t a qqu ualiliff i ed eell e c tr i ci an . D ON OT aatttemp o plu lugg . IIff iitt ssttill ddo no DO NO mptt tto d e feat oorr oovv er r id e tth h is ssaafet y ffeeatur uree . • ALWAYS UN PLU G aan n d eemp mp he vvaa p or iz er w hen iitt iiss n ot in oop p er ati on oorr w hililee iitt iiss bbeein UNP LUG mptt y tth wh no wh ingg emp ill mptti ed, ffill illeed oorr ccll e an ed. • DO N OT ttil ililtt oorr m o v e tth h e vvaap o ri zer w h ililee iitt iiss in oop p e r at i o n . NO mo wh • DO N OT dir o w ard s p he w ur n itur on ot p h e vvaap o r iz er un d er NO diree c t sstte am tto pee op l e, tth waa ll oorr ffur urn uree. D Do no pll ace tth und a tteent . • DO N OT tto o uch tth h e un in ot aan n d bbur ur ns ccaan oocccur NO uniit oorr sstteam vvaap o rs dur durin ingg uuss e . SStteam iiss hho urn ur.. • DO N OT aad dd m ny ttyy p e in he w h e cco o nt ain on o t cco ov er tth h e sstte am NO mee di diccati o n ooff aan intto tth waater in tth ineer. D Do no o utl et oorr p ny th in hililee tth he vvaap or iz er pll ace aan ingg oovv er iitt w wh is oop p er atin ny oob bj e c t in ingg . N Neev er ddrro p oorr in inss er t aan intto any oop p enin ingg . using your vaporizer 1. 2. 3. 4. 5. Remove the plastic covering from the vaporizer. Remove the tape from the water level indicator. Unravel and straighten out the cord before use. Always unplug the cord from the electrical outlet and the steam unit before removing the steam unit or when not in use. Allow vaporizer to cool before handling. Remove the steam unit from the ToteAwayTM tank. Twist the steam unit counterclockwise and lift it out of the ToteAwayTM tank. Refer to Figure A & B. Fill the ToteAwayTM tank with tap water. Fill the container until the water level indicator shows the MAX marking. Refer to Figure C. DO NOT OVERFILL. Add salt. For tap water of low or moderate mineral content, add 4 to 5 pinches (1/8 teaspoon) of ordinary table salt to the water and mix thoroughly. Salt has no effect on the purity of the steam or medication. If an adequate steam flow is not obtained after ten minutes, add another pinch or two as needed and mix thoroughly. If you live in a “hard-water” area, the vaporizer may operate well without salt additive. Fi gur uree A Steam Unit Fi gur uree B C AU T IO N: T o ilin To mucch ssaal t ccaan ccaau s e ex excces si sivv e bbo ilingg oorr a o o mu use. bl ow n ffu 6. Replace the steam unit. Align the arrows as shown and twist clockWater Level wise to lock back in place. Refer to Figure A & B. Indicator 7. Place the vaporizer in a safe position. Vaporizer should always be placed on a firm, flat surface at least four feet away from the bedside and out of the reach of the patient and children. Be sure the vaporizer is in a stable position and the power cord is out of the way to prevent the vaporizer from being upset or tipped over. Fi gur uree C NOTE: Protect the floor, rug or furniture by placing the vaporizer on a non-metallic, waterproof, heat-resistant surface. C AU TI ON: D on o t dir Do no diree c t sstteam ffll o w dir direec t ly aatt p paati en t , w waallllss o r ffur ur ni tur ou w ill ssttill oob bt ain tth h e ddeesir urn uree . Y Yo will sireed llee vel ooff hum humii di ditt y. Ke ep oou ut ooff tth h e rreeach ooff cch hilild d ren . SSttea m ccaa n ccaau s e bbur ur ns . urn 8. When using vaporizer medications, fill the medicine cup on the steam unit as directed by the instructions on the medicine package. Refer to Figure E. C AU TI ON: D on ot aad dd m ny ttyy p e in he w Do no mee di dicc ati on ooff aan intto tth waater in tth he T o teA way TM ttaank . To eAw Figur uree D 9. Plug in the unit. Firmly insert the plug in the steam unit. The 2-inTM TM 1 Easy Lock feature prevents you from inserting the plug into the steam unit until the steam unit is locked in place. Refer to Figure D. Plug the power cord into 110-120 Volts AC outlet in good condition fused for at least 15 Amps. DO NOT use with extension cords. han tth he ootth er) aass a ssaafet y lu n e bbll ad e iiss w o l ar iz ed p his p C AU TI ON: T wii d er tth plu lugg (o (on po prro du ducc t hhaas a p Th o t ffii t ffull ull he p lu o es n nl ne w utl et oonl o l ar iz e d oou lu ill ffiit in h is p featur ullyy in intto plu lugg ddo no waay. IIff tth nlyy oon will intto a p po uree. T Th plu lugg w ON OT u aliliff i ed eell ec tr i ci an . D o t ffiit , cco o nt ac t a qqu o es n he p lu th e oou utl et , rreev er s e tth DO NO no plu lugg . IIff iitt ssttill ddo attemp o ddeefe at oorr oovv err i d e tth his ssaafet y ffeeatur mptt tto uree . Use the Vari-MistTM selector to control the amount of vapors released. Vaporizer will produce a gentle flow of steam within a few minutes. If steaming does not start within ten minutes, you may need to add salt. Please see the troub ubll esh o otin ingg section. The vaporizer will automatically stop producing steam when the water has reached the minimum level which will be indicated when the water level indicator is showing MIN. Refer to Figure C. The NiteGloTM power light will remain on indicating that the vaporizer is still plugged in. ALWAYS unplug the steam unit and allow to cool before removing the ToteAwayTM tank. 10. Use fresh water and medication each time the vaporizer is used. 11. After each use, open the Easy Drain plug and empty any unused water from the ToteAwayTM tank. Refer to Figure F. Shake the ToteAwayTM tank gently back and forth to remove any remaining Medicine Cup water. Rinse the ToteAwayTM tank thoroughly, drain and wipe with a dry, clean cloth. All medicinal ingredients should be released in use, leaving only the mineral oil base in the removable medicine cup. The medicine cup may be removed and cleaned. Refer to Figure E. Fi gur uree E Both the ToteAwayTM tank and the removable medicine cup are dishwasher safe. nd IMPORTANT: To maintain proper operation of your vaporizer, be sure to follow the cl ean in ingg aan c are instructions. cleaning and care ALWAYS disconnect the plug from the electrical outlet and the plug from the steam unit and allow the unit to cool before cleaning. Remove the steam unit, letting all water drain back into the ToteAwayTM tank. The 2-in-1TM Easy LockTM feature prevents you from removing the steam unit until the plug is removed from the steam unit. DO NOT attempt to disassemble the steam unit. daily maintenance Open the Easy Drain plug and empty any unused water from the Figur uree F ToteAwayTM tank. Refer to Figure F. Rinse the ToteAwayTM tank thoroughly with water, drain and wipe with a dry, clean cloth. Remove and clean the removable medicine cup. Both the ToteAwayTM tank and the removable medicine cup are dishwasher safe. weekly maintenance 1. 2. 3. 4. 5. Open the Easy Drain plug and empty unused water from the ToteAwayTM tank. Refer to Figure F. Create a 50/50 solution of vinegar and water which should be 1/2 gallon vinegar and 1/2 gallon water. Pour this solution into the ToteAwayTM tank. Be sure to only fill the tank to the MAX line as indicated on the water level indicator. Refer to Figure C. With the steam unit safely unplugged, place the steam unit back into the ToteAwayTM tank and soak for 30 minutes. After soaking for 30 minutes, remove the steam unit. Empty the solution from the tank and rinse the tank. Fill the tank with tap water to the MAX line as indicated on the water level indicator. Refer to Figure C. Place the steam unit back into the tank for 30 seconds. Remove the steam unit and empty the water. Repeat the rinsing steps until the vinegar smell is gone. The ToteAwayTM tank has built-in antimicrobial properties to inhibit the growth of bacteria, mold and fungi that may affect the tank. To clean, empty the tank and rinse with tap water until the vinegar smell is gone. Dry with a clean cloth. Remove and clean the removable medicine cup. Both the ToteAwayTM tank and the removable medicine cup are dishwasher safe. end-of-season maintenance Follow the weekly maintenance procedure at end-of-season or when the vaporizer will not be used for several days. Be sure to dry all parts and store in a cool, dry location. Do not store unit with water inside. troubleshooting A. Vap o r iz er ddo o es n ot oop p er ate oorr sstteams tto o o ssll o wly : no 1. Make sure the vaporizer is plugged in and the NiteGloTM power light is on. If the NiteGloTM power light is not on, you may have a blown fuse, tripped circuit breaker or a defective electrical outlet. Try a different outlet. You may want to contact an electrician to check the potentially defective outlet. 2. The fault may be the low mineral content of the water in your area. Unplug the vaporizer from the electrical outlet and allow to cool. Remove the steam unit allowing hot water to first dribble out, then add one or two pinches of salt to the water and mix thoroughly. Replace the steam unit and plug in the vaporizer. It should steam within 5 minutes.