Download DEH-3400UB/XNUC DEH-3400UB/XNEW5
Transcript
ORDER NO. CRT4720 DEH-34UB/XNUC CD RDS RECEIVER DEH-34UB DEH-3400UB DEH-3400UB DEH-3450UB DEH-3450UB DEH-3490UB /XNUC /XNUC /XNEW5 /XNES /XNES1 /XNID This service manual should be used together with the following manual(s): Model No. CX-3287 Order No. CRT4759 Mech. Module S11.6STD Remarks CD Mech. Module : Circuit Descriptions, Mech. Descriptions, Disassembly PIONEER CORPORATION 1-1, Shin-ogura, Saiwai-ku, Kawasaki-shi, Kanagawa 212-0031, Japan PIONEER ELECTRONICS (USA) INC. P.O. Box 1760, Long Beach, CA 90801-1760, U.S.A. PIONEER EUROPE NV Haven 1087, Keetberglaan 1, 9120 Melsele, Belgium PIONEER ELECTRONICS ASIACENTRE PTE. LTD. 253 Alexandra Road, #04-01, Singapore 159936 PIONEER CORPORATION 2011 K-ZZZ JULY 2011 Printed in Japan 1 2 3 4 SAFETY INFORMATION CAUTION A This service manual is intended for qualified service technicians; it is not meant for the casual do-it-yourselfer. Qualified technicians have the necessary test equipment and tools, and have been trained to properly and safely repair complex products such as those covered by this manual. Improperly performed repairs can adversely affect the safety and reliability of the product and may void the warranty. If you are not qualified to perform the repair of this product properly and safely, you should not risk trying to do so and refer the repair to a qualified service technician. WARNING This product may contain a chemical known to the State of California to cause cancer, or birth defects or other reproductive harm. Health & Safety Code Section 25249.6 - Proposition 65 B Where in a manufacturer’s service documentation, for example in circuit diagrams or lists of components, a symbol is used to indicate that a specific component shall be replaced only by the component specified in that documentation for safety reasons, the following symbol shall be used: - Safety Precautions for those who Service this Unit. When checking or adjusting the emitting power of the laser diode exercise caution in order to get safe, reliable results. C Caution: 1. During repair or tests, minimum distance of 13 cm from the focus lens must be kept. 2. During repair or tests, do not view laser beam for 10 seconds or longer. CAUTION: USE OF CONTROLS OR ADJUSTMENTS OR PERFORMANCE OF PROCEDURES OTHER THAN THOSE SPECIFIED HEREIN MAY RESULT IN HAZARDOUS RADIATION EXPOSURE. CAUTION This product is a class 1 laser product classified under the Safety of laser products, IEC 60825-1:2007, and contains a class 1M laser module. To ensure continued safety, do not remove any covers or attempt to gain access to the inside of the product. Refer all servicing to qualified personnel. D CAUTION—CLASS 1M INVISIBLE LASER RADIATION WHEN OPEN, DO NOT VIEW DIRECTLY WITH OPTICAL INSTRUMENTS. E WARNING! The AEL (accessible emission level )of the laser power output is less than CLASS 1 but the laser component is capable of emitting radiation exceeding the limit for CLASS 1. A specially instructed person should do servicing operation of the apparatus. F 2 DEH-34UB/XNUC 1 2 3 4 5 6 7 8 A Laser diode characteristics Wave length : 785 nm to 814 nm Maximum output : 1 190 µW(Emitting period : unlimited) Additional Laser Caution Transistors Q101 in PCB drive the laser diodes. When Q101 is shorted between their terminals, the laser diodes will radiate beam. If the top cover is removed with no disc loaded while such short-circuit is continued, the naked eyes may be exposed to the laser beam. B CAUTION Danger of explosion if battery is incorrectly replaced. Replaced only with the same or equivalent type recommended by the manufacture. Discord used batteries according to the manufacture's instructions. C D E F DEH-34UB/XNUC 5 6 7 8 3 1 2 3 4 CONTENTS SAFETY INFORMATION..................................................................................................................................... 2 1. SERVICE PRECAUTIONS ............................................................................................................................... 5 1.1 SERVICE PRECAUTIONS ........................................................................................................................ 5 1.2 NOTES ON SOLDERING .......................................................................................................................... 6 2. SPECIFICATIONS ............................................................................................................................................ 7 2.1 SPECIFICATIONS ..................................................................................................................................... 7 2.2 DISC/CONTENT FORMAT ........................................................................................................................ 9 3. BASIC ITEMS FOR SERVICE........................................................................................................................ 10 3.1 CHECK POINTS AFTER SERVICING..................................................................................................... 10 3.2 PCB LOCATIONS .....................................................................................................................................11 3.3 JIGS LIST ................................................................................................................................................ 12 3.4 CLEANING............................................................................................................................................... 12 4. BLOCK DIAGRAM.......................................................................................................................................... 14 5. DIAGNOSIS.................................................................................................................................................... 16 5.1 OPERATIONAL FLOWCHART ................................................................................................................ 16 5.2 ERROR CODE LIST ................................................................................................................................ 17 5.3 CONNECTOR FUNCTION DESCRIPTION ............................................................................................. 19 6. SERVICE MODE ............................................................................................................................................ 20 6.1 DISPLAY TEST MODE ............................................................................................................................ 20 6.2 CD TEST MODE ...................................................................................................................................... 21 7. DISASSEMBLY .............................................................................................................................................. 22 8. EACH SETTING AND ADJUSTMENT ........................................................................................................... 28 8.1 CD ADJUSTMENT................................................................................................................................... 28 8.2 CHECKING THE GRATING AFTER CHANGING THE PICKUP UNIT.................................................... 29 8.3 PCL OUTPUT CONFIRMATION.............................................................................................................. 31 9. EXPLODED VIEWS AND PARTS LIST.......................................................................................................... 32 9.1 PACKING ................................................................................................................................................. 32 9.2 EXTERIOR............................................................................................................................................... 34 9.3 CD MECHANISM MODULE..................................................................................................................... 36 10. SCHEMATIC DIAGRAM............................................................................................................................... 38 10.1 TUNER AMP UNIT (GUIDE PAGE) ....................................................................................................... 38 10.2 KEYBOARD UNIT.................................................................................................................................. 44 10.3 CD CORE UNIT (S11.6STD) ................................................................................................................. 46 10.4 WAVEFORMS ........................................................................................................................................ 48 11. PCB CONNECTION DIAGRAM.................................................................................................................... 50 11.1 TUNER AMP UNIT................................................................................................................................. 50 11.2 KEYBOARD UNIT .................................................................................................................................. 54 11.3 CD CORE UNIT (S11.6STD).................................................................................................................. 56 12. ELECTRICAL PARTS LIST .......................................................................................................................... 58 A B C D E F 4 DEH-34UB/XNUC 1 2 3 4 5 6 7 8 1. SERVICE PRECAUTIONS 1.1 SERVICE PRECAUTIONS A 1. You should conform to the regulations governing the product (safety, radio and noise, and other regulations), and should keep the safety during servicing by following the safety instructions described in this manual. 2. Before disassembling the unit, be sure to turn off the power. Unplugging and plugging the connectors during power-on mode may damage the ICs inside the unit. 3. To protect the pickup unit from electrostatic discharge during servicing, take an appropriate treatment (shorting-solder) by referring to "the DISASSEMBLY". 4. After replacing the pickup unit, be sure to check the grating. 5. Be careful in handling ICs. Some ICs such as MOS type are so fragile that they can be damaged by electrostatic induction. 6. area and a heat sink becomes hot areas. Be careful not to burn yourself. B C D 7. Software update The software of this product is stored in IC671. Please replace IC671 when making the version upgrade of software. E F DEH-34UB/XNUC 5 6 7 8 5 1 2 3 4 A 8. Capacitor Bond Lock (UC, EW5) Acetate Tape (GYH1026) 1 Please stick acetate tape along white line. 2 Please confirm line hiding with acetate tape. * length of tape : 24 ± 4 mm 1 2 B 9. Capacitor Bond Lock (ID, ES, ES1) Silicon Glue (GEM1017) Place the capacitor in the center of the silk print, and confirm it does not touch to the connector. Then, apply silicon glue. NG OK C 1.2 NOTES ON SOLDERING D For environmental protection, lead-free solder is used on the printed circuit boards mounted in this unit. Be sure to use lead-free solder and a soldering iron that can meet specifications for use with lead-free solders for repairs accompanied by reworking of soldering. Compared with conventional eutectic solders, lead-free solders have higher melting points, by approximately 40 C. Therefore, for lead-free soldering, the tip temperature of a soldering iron must be set to around 373 C in general, although the temperature depends on the heat capacity of the PC board on which reworking is required and the weight of the tip of the soldering iron. Compared with eutectic solders, lead-free solders have higher bond strengths but slower wetting times and higher melting temperatures (hard to melt/easy to harden). E The following lead-free solders are available as service parts: Parts numbers of lead-free solder: GYP1006 1.0 in dia. GYP1007 0.6 in dia. GYP1008 0.3 in dia. F 6 DEH-34UB/XNUC 1 2 3 4 5 6 7 8 2. SPECIFICATIONS 2.1 SPECIFICATIONS A DEH-3400UB/XNUC, DEH-34UB/XNUC General Power source ................. 14.4 V DC (10.8 V to 15.1 V allowable) Grounding system ........... Negative type Maximum current consumption ................................ 10.0 A Backup current ................ 4.0 mA or less Dimensions (W × H × D): DIN Chassis .............. 178 mm × 50 mm × 165 mm (7 in. × 2 in. × 6-1/2 in.) Nose .................. 188 mm × 58 mm × 16 mm (7-3/8 in.× 2-1/4 in.× 5/8 in.) D Chassis .............. 178 mm × 50 mm × 165 mm (7 in.× 2 in.× 6-1/2 in.) Nose .................. 170 mm × 46 mm × 16 mm (6-3/4 in.× 1-3/4 in.× 5/8 in.) Weight ............................. 1.1 kg (2.4 lbs) Usable discs ....................Compact disc Signal-to-noise ratio ......... 94 dB (1 kHz) (IHF-A network) Number of channels ........ 2 (stereo) MP3 decoding format ...... MPEG-1 & 2 Audio Layer 3 WMA decoding format ..... Ver. 7, 7.1, 8, 9, 10, 11, 12 (2 ch audio) (Windows Media Player) WAV signal format ...........Linear PCM & MS ADPCM (Non-compressed) USB B USB standard specification ................................... USB 2.0 full speed Maximum current supply ................................... 1 A USB Class ....................... MSC (Mass Storage Class) File system....................... FAT12, FAT16, FAT32 MP3 decoding format ...... MPEG-1 & 2 Audio Layer 3 WMA decoding format ..... Ver. 7, 7.1, 8, 9, 10, 11, 12 (2 ch audio) (Windows Media Player) WAV signal format ...........Linear PCM & MS ADPCM (Non-compressed) FM tuner Audio Maximum power output ... 50 W × 4 Continuous power output ................................... 22 W × 4 (50 Hz to 15 000 Hz, 5 % THD, 4 Ω load, both channels driven) Load impedance .............. 4 Ω (4 Ω to 8 Ω allowable) Preout maximum output level ................................... 2.0 V Tone controls: Bass Frequency .......... 100 Hz Gain .................. ±12 dB Mid Frequency .......... 1 kHz Gain .................. ±12 dB Treble Frequency .......... 10 kHz Gain .................. ±12 dB Subwoofer (mono): Frequency ................. 50 Hz/63 Hz/80 Hz/100 Hz/ 125 Hz Slope ........................–18 dB/oct Gain ......................... +6 dB to –24 dB Phase ....................... Normal/Reverse CD player Frequency range ............. 87.9 MHz to 107.9 MHz Usable sensitivity ............. 9 dBf (0.8 µV/75 Ω, mono, S/N: 30 dB) Signal-to-noise ratio ......... 72 dB (IHF-A network) C AM tuner Frequency range .............. 530 kHz to 1 710 kHz Usable sensitivity ............. 25 µV (S/N: 20 dB) Signal-to-noise ratio ......... 62 dB (IHF-A network) CEA2006 Specifications D Power output ................... 14 W RMS × 4 Channels (4 Ω and < = 1 % THD+N) S/N ratio .......................... 91 dBA (reference: 1 W into 4 Ω) Note Specifications and the design are subject to modifications without notice. System ............................ Compact disc audio system E Securing the front panel The front panel can be secured with the supplied screw. F Screw (BPZ20P060FTC) (UC) (XXX7020) (EW5, ID, ES) DEH-34UB/XNUC 5 6 7 8 7 1 2 3 4 A DEH-3400UB/XNEW5 General CD player Power source ................. 14.4 V DC (10.8 V to 15.1 V allowable) Grounding system ........... Negative type Maximum current consumption ................................ 10.0 A System .......................... Compact disc audio system Usable discs ...................Compact disc Signal-to-noise ratio ......... 94 dB (1 kHz) (IEC-A network) Number of channels ........ 2 (stereo) MP3 decoding format ...... MPEG-1 & 2 Audio Layer 3 WMA decoding format ..... Ver. 7, 7.1, 8, 9, 10, 11, 12 (2 ch audio) (Windows Media Player) WAV signal format ...........Linear PCM & MS ADPCM (Non-compressed) Backup current ................ 4.0 mA or less Dimensions (W × H × D): DIN Chassis .............. 178 mm × 50 mm × 165 mm Nose .................. 188 mm × 58 mm × 16 mm D Chassis .............. 178 mm × 50 mm × 165 mm Nose .................. 170 mm × 46 mm × 16 mm Weight ............................. 1.1 kg B USB Audio Maximum power output ... 50 W × 4 Continuous power output ................................... 22 W × 4 (50 Hz to 15 000 Hz, 5 % THD, 4 Ω load, both channels driven) Load impedance .............. 4 Ω (4 Ω to 8 Ω allowable) Preout maximum output level ................................... 2.0 V Tone controls: Bass Frequency .......... 100 Hz Gain .................. ±12 dB Mid Frequency .......... 1 kHz Gain .................. ±12 dB Treble Frequency .......... 10 kHz Gain .................. ±12 dB Subwoofer (mono): Frequency ................. 50 Hz/63 Hz/80 Hz/100 Hz/ 125 Hz Slope ........................–18 dB/oct Gain ......................... +6 dB to –24 dB Phase .......................Normal/Reverse C D USB standard specification ................................... USB 2.0 full speed Maximum current supply ................................... 500 mA USB Class ....................... MSC (Mass Storage Class) File system....................... FAT12, FAT16, FAT32 MP3 decoding format ...... MPEG-1 & 2 Audio Layer 3 WMA decoding format ..... Ver. 7, 7.1, 8, 9, 10, 11, 12 (2 ch audio) (Windows Media Player) WAV signal format ...........Linear PCM & MS ADPCM (Non-compressed) FM tuner Frequency range ............. 87.5 MHz to 108.0 MHz Usable sensitivity ............. 9 dBf (0.8 µV/75 Ω, mono, S/N: 30 dB) Signal-to-noise ratio ......... 72 dB (IEC-A network) MW tuner Frequency range .............. 531 kHz to 1 602 kHz Usable sensitivity ............. 25 µV (S/N: 20 dB) Signal-to-noise ratio ......... 62 dB (IEC-A network) LW tuner Frequency range .............. 153 kHz to 281 kHz Usable sensitivity ............. 28 µV (S/N: 20 dB) Signal-to-noise ratio ......... 62 dB (IEC-A network) Note Specifications and the design are subject to modifications without notice. E F 8 DEH-34UB/XNUC 1 2 3 4 5 6 7 8 A DEH-3450UB/XNES, XNES1, DEH-3490UB/XNID General WMA decoding format ..... Ver. 7, 7.1, 8, 9, 10, 11, 12 (2 ch audio) (Windows Media Player) WAV signal format ...........Linear PCM & MS ADPCM (Non-compressed) Rated power source .........14.4 V DC (allowable voltage range: 12.0 V to 14.4 V DC) Grounding system ............Negative type Maximum current consumption ................................ 10.0 A Backup current ................ 4.0 mA or less USB USB standard specification ................................... USB 2.0 full speed Maximum current supply ................................... 1 A USB Class ....................... MSC (Mass Storage Class) File system....................... FAT12, FAT16, FAT32 MP3 decoding format ...... MPEG-1 & 2 Audio Layer 3 WMA decoding format ..... Ver. 7, 7.1, 8, 9, 10, 11, 12 (2 ch audio) (Windows Media Player) WAV signal format ...........Linear PCM & MS ADPCM (Non-compressed) Dimensions (W × H × D): DIN Chassis .............. 178 mm × 50 mm × 165 mm Nose .................. 188 mm × 58 mm × 16 mm D Chassis .............. 178 mm × 50 mm × 165 mm Nose .................. 170 mm × 46 mm × 16 mm Weight ............................. 1.1 kg B FM tuner Audio Maximum power output ... 50 W × 4 Continuous power output ................................... 22 W × 4 (50 Hz to 15 000 Hz, 5 % THD, 4 Ω load, both channels driven) Load impedance .............. 4 Ω (4 Ω to 8 Ω allowable) Preout maximum output level ................................... 2.0 V Tone controls: Bass Frequency .......... 100 Hz Gain .................. ±12 dB Mid Frequency .......... 1 kHz Gain .................. ±12 dB Treble Frequency .......... 10 kHz Gain .................. ±12 dB Subwoofer (mono): Frequency ................. 50 Hz/63 Hz/80 Hz/100 Hz/ 125 Hz Slope ........................–18 dB/oct Gain ......................... +6 dB to –24 dB Phase ....................... Normal/Reverse CD player System .......................... Compact disc audio system Usable discs ...................Compact disc Signal-to-noise ratio ......... 94 dB (1 kHz) (IEC-A network) Number of channels ........ 2 (stereo) MP3 decoding format ...... MPEG-1 & 2 Audio Layer 3 Frequency range ............. 87.5 MHz to 108.0 MHz Usable sensitivity ............. 9 dBf (0.8 µV/75 Ω, mono, S/N: 30 dB) Signal-to-noise ratio ......... 72 dB (IEC-A network) C MW tuner Frequency range .............. 531 kHz to 1 602 kHz (9 kHz) 530 kHz to 1 640 kHz (10 kHz) Usable sensitivity ............. 25 µV (S/N: 20 dB) Signal-to-noise ratio ......... 62 dB (IEC-A network) SW tuner Frequency range .............. 2 300 kHz to 7 735 kHz (2 300 kHz to 2 495 kHz, 2 940 kHz to 4 215 kHz, 4 540 kHz to 5 175 kHz, 5 820 kHz to 6 455 kHz, 7 100 kHz to 7 735 kHz) 9 500 kHz to 21 975 kHz (9 500 kHz to 10 135 kHz, 11 580 kHz to 12 215 kHz, 13 570 kHz to 13 870 kHz, 15 100 kHz to 15 735 kHz, 17 500 kHz to 17 985 kHz, 18 015 kHz to 18 135 kHz, 21 340 kHz to 21 975 kHz) Usable sensitivity ............. 28 µV (S/N: 20 dB) Signal-to-noise ratio ......... 62 dB (IEC-A network) D Note Specifications and the design are subject to modifications without notice. E 2.2 DISC/CONTENT FORMAT F DEH-34UB/XNUC 5 6 7 8 9 1 2 3 4 3. BASIC ITEMS FOR SERVICE 3.1 CHECK POINTS AFTER SERVICING A To keep the product quality after servicing, please confirm following check points. No. 1 4 Procedures Confirm whether the customer complain has been solved. If the customer complain occurs with the specific media, use it for the operation check. Play back a CD. (Track search) Check FM/AM tuner action. (Seek, Preset) Switch band to check both FM and AM. Check whether no disc is inside the product. 5 Appearance check 2 CD 3 FM/AM tuner B Item to be confirmed The customer complain must not be reappeared. Display, audio and operations must be normal. No malfunction on display, audio and operation. Display, audio and operations must be normal. The media used for the operating check must be ejected. No scratches or dirt on its appearance after receiving it for service. See the table below for the items to be checked regarding audio: Item to be checked regarding audio Distortion Noise Volume too low Volume too high Volume fluctuating Sound interrupted C D E F 10 DEH-34UB/XNUC 1 2 3 4 5 6 7 8 3.2 PCB LOCATIONS A C CD Core Unit (S11.6STD) B A Tuner Amp Unit C B Keyboard Unit A:DEH-34UB/XNUC B:DEH-3400UB/XNUC D C:DEH-3400UB/XNEW5 D:DEH-3450UB/XNES E:DEH-3450UB/XNES1 F:DEH-3490UB/XNID Unit Number : QWM3310(A,B) : QWM3309(C) : QWM3311(D,E,F) Unit Name : Tuner Amp Unit Unit Number : (A,B,D,E,F) E : (C) Unit Name : Keyboard Unit Unit Number : CWX4023 Unit Name : CD Core Unit (S11.6STD) F DEH-34UB/XNUC 5 6 7 8 11 1 2 3 4 3.3 JIGS LIST - Jigs List A Name 16P FFC Test Disc L.P.F. Acetate Tape Silicon Glue Jig No. GGD1310 TCD-782 GYH1026 GEM1017 Remarks Tuner Amp Unit - CD Core Unit Checking the grating Checking the grating (Two pieces) Capacitor Bond Lock Capacitor Bond Lock Grease No. GEM1024 GEM1038 GEM1043 GEM1045 Remarks CD Mechanism Module CD Mechanism Module CD Mechanism Module CD Mechanism Module - Grease List Name Grease Grease Grease Grease B C 3.4 CLEANING Before shipping out the product, be sure to clean the following portions by using the prescribed cleaning tools: D Portions to be cleaned CD pickup lenses Cleaning tools Cleaning liquid : GEM1004 Cleaning paper : GED-008 E F 12 DEH-34UB/XNUC 1 2 3 4 5 6 7 8 A B C D E F DEH-34UB/XNUC 5 6 7 8 13 1 2 3 4 4. BLOCK DIAGRAM A A TUNER AMP UNIT JA401 1 ANTENNA 5 16 2,3 18 FMMIXIN1 57 DACOUTL PINDIN LNAIN RF FRONT END IC IC401 TDA7706 I2CSCL I2CSDA RSTN 34 112 33 111 31 107 DAC IC231 PCM1753DBQ TUNSCL TUNSDA TUNPCE1 DACCS DACSCK B WIRED REMOTE JA892 DACLRCK 2 KEYAD DACDATA 69 129 3 KEYD KEYAD KEYD 1 GND DACBDATA DACBSCK AUDIO_XOUT 124 15 91 1 89 3 88 2 87 13 85 14 84 16 ML BCK LRCK DATA VOUTL 7 MD MC SCK iPod CP IC551 341S2162 Q551 2 MODE1 RESET VDD3.3V 5 VCC RES 118 I2C_SCL I2C_SDA nRESET 12 114 13 113 4 116 38 VS IC651 S-80827CNMC-B8M 1 VD VC CPPWR ILMPW Q874 CP_SCL B.UP CP_SDA ILM+B CPRST MUT Q873 ILMPW C FLASH ROM IC671 A B :PEB012A8 C D E F :PEB011A8 132 SYSTEM MICRO COMPUTER IC601 (1/2) R5S7266ZD144FP TEL REGULATOR IC IC912 BA49182-V12 ASEN A :DEH-34UB/XNUC B :DEH-3400UB/XNUC C :DEH-3400UB/XNEW5 D :DEH-3450UB/XNES E :DEH-3450UB/XNES1 F :DEH-3490UB/XNID 6 SW5V 9 SWVDD 7 VDD3.3V 8 VDD1.2V 5 SYS+B VDDCONT SW5V BSENS SWVDD SYSPW VDD SW5VCNT 11 128 1 141 2 7 +B +BUP BSENS SYSPW 3 VDD12 SYS+B SWVDD 4 SYSTEM MICRO COMPUTER IC601 (2/2) R5S7266ZD144FP B.UP 10 SSEN USB5V REGULATOR D C PICKUP UNIT (P10.6)(SERVICE) IC501 BD9008F ROT CD CORE UNIT(S11.6 STD) 8 CN101 12 VCC LD LD- MD 15 MD 5 12 15 V+3A IC510 BD2232G-G RF AMP, CD DECODER DIGITAL SERVO/DATA • PROCESSOR CPU VDD GND 1 Q101 VIN 8 2 93 REFO FOM TRACKING ACT. E FOP 3 5 3 3 2 2 PD V+3A VDD REFOUT PUEN USB5V 54 CN701 ACTUATOR/ MOTOR DRIVER INV KYD EN 5 VOUT OC 3 18 4 20 VDD VDD USBCTL DP USBFLG VBUS DSEN CN701 9 9 VDD VDD3.3V IC301 BD8223EFV 1 TOP TOM 4 4 TOM TD,FD 14 LD+ SD,MD 14 SYNC FB 54 IC201 PE5791A FOP 19 SW Q102 FOM TOP 1 LD+ 8 7 10 9 SOP VD VD TKO- 2 2 1 1 VD VDSENS RGB Q751 ILMCL B.UP ILMCL Q752 FCO+ FCO- M SOM 3 SPO+ 2 SPO- LOADING/CARRIAGE MOTOR M LCOP LCOM 5 4 14 23 40 22 41 MUTE 21 39 CNT LDIN SLLDO+ SLLDO- 38 35 S903 DSCSNS 67 MECHA VD TKO+ SPINDLE MOTOR F 2 AC,BD,E,F HOLOGRAM UNIT FOCUS ACT. ROT VIN 4 5 PD 8 PVIN EN/ SYNC 1 LD REFO VREF 1 B.UP VDCONT CLCONT LOEJ CONT DSCSNS RESET RESET 29 8 CD DATA (CDSRQ,CDSTBY,SKIP, SCL,SDA,DATA,BCLK,LRCK,WAIT) 8 RESET 120 CDRST CD DATA (CDSRQ,CDSTBY,SKIP, SCL,SDA,DATA,BCLK,LRCK,WAIT) HOME S901 HOME D D 14 DEH-34UB/XNUC 1 2 3 4 5 6 7 8 A JA251 PL PL 2 1 PRE OUTPUT P251 RCAG Q251 C ELECTRONIC VOLUME/ SOURCE SELECTOR IC201 PML022A JA251 PL 3 RCAG FL CDL 1 AUXL 4 6 POUT_L IN2_L 1 6 RCAG IN1_L PRE OUTPUT 4 Q252 P251 2 TUNL FL B A B D E F IN4+_L JA901 7 FRONT_L VST VDT VCK 26 15 27 13 30 14 11 8 REAR_L FLIn 12 STB RLIn FL+ MUTE DATA AMP IC301 PAL007E Q351 (1/2) CLK FLRL+ RL- 22 Q351 (2/2) MUTE 18 B.UP FL+ 7 FL- 5 RL+ 3 RL- 25 B.REM MUTE 9 BREM 1 3 5 7 14 POWER CONNECTOR 21 C TELIN Q941 TELIN 9 TEL C ASENS 9 ASENS Q931 143 ACC 13 SWVDD BSENS B SYSPW SYSTEM MICRO COMPUTER IC601 (2/2) R5S7266ZD144FP CN801 AUXL KEYBOARD UNIT JA1921 CN1821 19 19 18 18 S1826 SSENS SOURCE 142 SOURCE SRC ROTARY COMMANDER S1827 S1842 ROT0 ROT1 131 ROT0 130 ROT1 6 6 4 4 ROT0 2 5 KDT2 ROT1 1 4 KST1 D 3 SYNC ILM+B 5 5 ILM+B SWVDD 3 3 SWVDD KDT0 KDT1 KDT2 KDT3 KYDT USBCTL DPDT KYDT 29 8 8 20 KYDT KST0 KYDT IC801 TC7SET08FUS1 28 2 4 DPDT 10 10 18 DPDT DPDT USBFLG VBUS DSENS 140 DSENS 20 20 KST1 LCD DRIVER/ KEY CONTROLLER IC1801 PD6581A KST2 KST3 KST4 ILMCLR2 ILMCLR1 137 RGBDT 135 RGBST 133 RGBCK 7 7 14 14 12 12 16 25 26 14 KEY MATRIX 13 12 11 28 LCD V1801 RGB DRIVER IC1851 BU2507FV RGBDT 15 DSENS REM VDSENS FRONT_AUX AUXR 3 AUXL 2 AUXGND 1 AUXL RGBDT 12 RGBST 10 RGBCK 11 17 REMOTE CONTROL SENSOR ILM+B 1 Q1868 BLUE LCD C DI LD AO6 9 Q1867 IC1802 GP1UXC14RK E A B D E F GREEN LCD CLK AO5 6 Q1866 RED LCD BLUE VDCONT AO4 5 Q1861 GREEN RED CDRST AO3 AO2 Q1852 3 DM DP 52 DM 53 DP 11 11 13 13 15 15 Q1853 Q1854 Q1863 Q1859 Q1864 Q1855 Q1860 Q1865 D1852 D1853 D1854 13 ILM+B ILM+B ILM+B DM DM DP DP 6 7 F CN1911 USB5V USB5V DEH-34UB/XNUC 5 Q1858 Q1851 ILM+B USB5V Q1862 2 D1851 AO1 Q1857 Q1856 2 3 USB 4 8 15 1 2 3 4 5. DIAGNOSIS 5.1 OPERATIONAL FLOWCHART A Power ON Vcc = 1.2 V Pin 5 PVcc = 3.3 V Pin 1 BSENS B Pin 141 BSENS = L ASENS Pin 143 ASENS = L C DSENS Pin 140 DSENS = L Starts communication with Grille microcomputer. D 300 ms SWVDD <- H Pin 128 300 ms In case of the above signal, the communication with Grille microcomputer may fail. If the time interval is not 300 msec, the oscillator may be defective. Source keys operative E Source ON SYSPW <- H Pin 7 F Completes power-on operation. (After that, proceed to each source operation) 16 DEH-34UB/XNUC 1 2 3 4 5 6 7 8 5.2 ERROR CODE LIST ERROR CODES A If a CD memory device is inoperable, or operation of such media is stopped by an error, the error mode is established and a cause of the error is displayed by an error code. Indication of error codes is intended to reduce the number of calls from customers and facilitate failure analysis and repair work in servicing. (1) DISPLAY METHOD If “0xFD” error mode is displayed in CD MODE (CD MODE area for display), an error code will be displayed in the MIN (minute display) and SEC (second display) areas. The same code is displayed in the MIN and SEC areas. The TNO area is blank (#0FFH), as it conventionally was. • Display example of the head unit Depending on the display capability of LCDs, the display format varies, as shown below. XX denotes an error number. Note: In a case of an OEM product, the error display format is subject to the specifications used by the equipment manufacturer. 8-digit display 6-digit display ERROR-xx ERR-xx B 4-digit display E-xx (2) LIST OF CD ERROR CODES (Error Mode: 0xFD) Code Classification Error code to be displayed Details and possible causes 07 Servo TOC reading NG TOC information cannot be read. --> The partial disk or TOC content is illegal. 10 Servo Carriage Home NG 11 Servo Focus NG The pickup cannot move toward the inner track. The CRG cannot move from the inner track. --> Defective HOME SW; Failure in CRG movement. Focusing not available --> Disc placed upside-down; Stains on the disc; excessive vibration. 12 Servo Spindle Lock NG Subcode NG RF-amp NG Spindle not locked. Subcode not readable. Proper RF AMP gain not obtained. --> Defective spindle; Scratches or stains on the disc; excessive vibration. --> A CD-R/RW disc that does not contain data loaded, or in a rare case, disc placed upside-down. --> RF signal error. 15 Servo RF NG The digital signal from the disc cannot be detected. --> A CD-R/RW disc that does not contain data loaded. 17 Servo Setup NG The laser output cannot be adjusted. Focus can be easily lost. --> Scratches or stains on the disc; excessive vibration. 30 Servo Search Time Out Failed to reach a target address. And, the search became a timeout. --> Carriage/Tracking error; Scratches on the disc; Stains on the disc 50 Mechanism Load NG Eject NG Disc loading/ejection not completed --> A foreign object inserted in the mechanism; Disc jammed. 51 Mechanism Failure in retried turning for ejection Disc could not be ejected even after disc turning had been retried. --> A foreign object inserted in the mechanism; Disc jammed. C D E NOTES • Indications of error codes are available only during disc operations, because CD operations are unavailable if a mechanical error is generated. • If the TOC cannot be read, It stops because of error 07. • If you design a new head unit, be sure to use one of the display formats indicated in “Display example of the head unit.” • The 2 high-order digits of an error code denote the main classification, shown below. code classification 0x 1x Servo-related errors 3x 5x Mechanism-related errors F • How to restore from each error is shown below. Servo-related errors(0X, 1X, 3X) : Servo-related errors CD Off, Eject, ACC Off, Back-up Off, Communication reset, Reset Load NG/Eject NG(50) : Reload, Eject, ACC Off, Back-up Off, Communication reset, Reset Failure in retried turning for ejection : CD On, Eject, ACC Off, Back-up Off, Communication reset, Reset DEH-34UB/XNUC 5 6 7 8 17 1 2 3 4 USB storage device/iPod A B Cause Action NO DEVICE When plug and play is off, no USB storage device or iPod is connected. Turn the plug and play on. Connect a compatible USB storage device/iPod. FRMT READ Sometimes there is a delay between the start of playback and when you start to hear any sound. Wait until the message disappears and you hear sound. NO AUDIO There are no songs. Transfer the audio files to the USB storage device and connect. The connected USB storage device has security enabled. Follow the USB storage device instructions to disable the security. The connected USB storage device contains files embedded with Windows Media™ DRM 9/ 10. Play an audio file not embedded with Windows Media DRM 9/10. All the files in the USB storage device are embedded with Windows Media DRM 9/10. Transfer audio files not embedded with Windows Media DRM 9/10 to the USB storage device and connect. The USB device connected to is not supported by this unit. Connect a USB Mass Storage Class compliant device. Disconnect your device and replace it with a compatible USB storage device. SKIPPED C PROTECT D N/A USB E ERROR-19 Cause Action The iPod operates correctly but does not charge. Make sure the connection cable for the iPod has not shorted out (e.g., not caught in metal objects). After checking, turn the ignition switch OFF and back ON, or disconnect the iPod and reconnect. Communication Perform one of failed. the following operations. –Turn the ignition switch OFF and back ON. –Disconnect the USB storage device. –Change to a different source. Then, return to the USB source. iPod failure. CHECK USB The USB connector or USB cable has shortcircuited. Check that the USB connector or USB cable is not caught in something or damaged. The connected USB storage device consumes more than 500 mA (maximum allowable current). Disconnect the USB storage device and do not use it. Turn the ignition switch to OFF, then to ACC or ON and then connect only compliant USB storage devices. F 18 Message Message Disconnect the cable from the iPod. Once the iPod’s main menu is displayed, reconnect the iPod and reset it. ERROR-23 USB storage device was not formatted with FAT12, FAT16 or FAT32. ERROR-16 The iPod firmware version is old. Update the iPod version. iPod failure. Disconnect the cable from the iPod. Once the iPod’s main menu is displayed, reconnect the iPod and reset it. There are no songs in the current list. Select a list that contains songs. STOP NOT FOUND No related songs. USB storage device should be formatted with FAT12, FAT16 or FAT32. Transfer songs to the iPod. DEH-34UB/XNUC 1 2 3 4 5 6 7 8 5.3 CONNECTOR FUNCTION DESCRIPTION A B WIRED REMOTE CONTROL ANTENNA 15 13 11 9 7 5 3 1 16 14 12 10 8 6 4 2 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 FL+ FR+ FLFRRL+ RR+ RLRR- FRONT OUTPUT (Except DEH-3400UB/XNEW5) REAR OUTPUT or SUBWOOFER OUTPUT NC NC NC NC ACC B.REM B.UP GND C D E F DEH-34UB/XNUC 5 6 7 8 19 1 2 3 4 6. SERVICE MODE 6.1 DISPLAY TEST MODE A The information such as the system microcomputer version is checked. [How to enter Test mode] Press “ 1 ” and “ 3 ” keys simultaneously to start resetting. [Operation key] Operation key Processing 1+3 Enter display test mode Switch to next test mode Remarks B [Test items] Start display test mode. (Press “ 1 ” + “ 3 ” keys simultaneously to start resetting.) Key Illumination Icon Off All off On (an initial value) All off * Initial condition System Version information is displayed. C S $ $ $ $ # # # 14SEG S $ $ $ $ # # # 5*5Dot $ PD number For PEA010A, "010A" is displayed # System microcomputer version For Ver.7.01, "701" is displayed On (an initial value or setting value of default menu) All off D Switching to next display by pressing “ 1 ” + “ 3 ” keys simultaneously. Display is normally updated Product operation is performed as usual, in appearance. On (an initial value or setting value of default Switching to next display menu) by pressing “ 1 ” + “ 3 ” keys simultaneously. E On (lighting condition of normal times) Display update is stopped The screen gets still when entering this item. Switching to next display by pressing “ 1 ” + “ 3 ” keys simultaneously. On (an initial value or setting value of default menu) On (state when entering test mode) F 20 DEH-34UB/XNUC 1 2 3 4 5 6 7 8 6.2 CD TEST MODE - Flow Chart [4]+[6]->BUP+ACC ON Test Mode IN A [Key] [CD] or [SOURCE] Source ON TRK Contents MIN Display [BAND] [2] RF AMP *1 Gain switching TRK MIN SEC Power On (T.Offset is adjusted) TRK MIN SEC 00 [BAND] MIN SEC [BAND] 91 91 SEC TRK MIN *2 TRK MIN SEC 0X 0X 0X TRK MIN SEC [>] 00 00 00 or 99 99 99 [3] ?? ?? ?? [3] F,T,RF AGC*5 F.Bias display switching TRK MIN SEC ?? ?? ?? [<] [2] CRG + CRG - *6 00 00 00 or 99 99 99 *6 00 00 00 or 99 99 99 [>] RF AGC / RF AGC coefficient display TRK MIN SEC SEC [1] Power Off GG Tracking Servo Close ?tr ?min ?sec [BAND] GG [1] Focus Mode switching [1] T.Close & AGC Applicable servomechanism Power Off MIN GG [6] Focus Close S curve check TRK MIN SEC 91 TRK 00 [3] Power Off TRK 00 Self-adjusting switching *3 MIN SEC ?? [<] CRG - 8X 8X 8X or 9X 9X 9X 8X 8X 8X or 9X 9X 9X [>] [<] CRG/TR Jump - *4 *4 ?tr ?min ?sec ?tr ?min ?sec MIN SEC TRK ?? T.Balance adjustment / T.BAL coefficient display TRK MIN SEC ?? ?? ?? [2] CRG/TR Jump + TRK ?? [2] CRG + F,T AGC / F.Bias RF AGC TRK MIN SEC B TRK MIN Tracking Open SEC ?tr ?min ?sec 8X 8X 8X or 9X 9X 9X C *6 [BAND] [2] Power Off TRK *1) MIN Tracking Open t TYP TRK 8X 8X 8X or 9X 9X 9X SEC MIN SEC *2) Focus Close t TRK 00MIN00SEC00 (TRK99MIN99SEC99) + 6 dB t TRK 06MIN06SEC06 S. Curve t 01MIN01SEC01 TRK + 12 dB TRK 12MIN12SEC12 F EQ measurement setting TRK 02MIN02SEC02 [Key] [BAND] [>] [<] [1] *3) F.Offset Display t RF.Offset t T.Offset Display t Switch to the order of the original display [2] [3] [6] *4) 100TR Jump Operation Test Mode Power On/Off CRG + / TR Jump + (Direction of the external surface) CRG - / TR Jump (Direction of the internal surface) T. CLS & AGC & Applicable servomechanism / AGC,AGC display setting RF Gain switching / Offset adjustment display / T.Balance adjustment / T. Open F. Close,S. Curve / Rough Servo and RF AGC / F,T,RF AGC F. Mode switching / Tracking Close D *5) TRK/MIN/SEC t F.AGC t T.AGC Gain t F.Bias t RF AGC E *6) CRG motor voltage = 2 [V] After the [EJECT] key is pressed keys other than the [EJECT] key should not be pressed, until disc ejection is complete. When the key [2] or [3] is pressed during the Focus Search, the power supply should be immediately turned off (otherwise the lens sticks to Wall, causing the actuator to be damaged). In the case of 100TR Jump, the mechanism shall be set to the Tracking Close mode when the key is released. When the power is turned on/off the gain of the RFAMP is reset to 0 dB. At the same time all the self-adjusting values shall return to the default setting. Do not do Tracking Servo Close before doing Focus Servo Close. (Because the overcurrent flows) DEH-34UB/XNUC 5 6 7 8 F 21 1 2 3 4 7. DISASSEMBLY While the photograph shown is slightly different from this model in shape, the disassembly procedure is the same. A - Removing the Panel Assy (Fig.1) 1 1 Remove the two hooks. 2 Remove the two hooks and then remove the Panel Assy. 1 2 2 Fig.1 Panel Assy B - Removing the CD Mechanism Module (Fig.2, 3, 4) 1 Remove the screw. 2 Remove the two screws. 1 2 2 Fig.2 C Heat sink side The CD Mechanism Module side is made a bottom. 3 3 Fig.3 3 Push the area and remove the two hooks. 4 Slide the Tuner Amp Assy in the direction of the arrow and then remove the hooks of upper and lower. Tuner Amp Assy CD Mechanism Module D Lift off the Tuner Amp Assy from the Heat sink side. 5 The Tuner Amp Assy is fixed into the ditch. E 5 6 Disconnect the FFC and then remove the CD Mechanism Module. 6 5 CD Mechanism Module Fig.4 F 22 DEH-34UB/XNUC 1 2 3 4 5 6 7 8 - Removing the Tuner Amp Unit (Fig.5) A 1 1 Remove the two screws. 2 Remove the two screws. 3 Straighten the tabs at two locations indicated and then remove the Tuner Amp Unit. 3 1 2 3 B 2 Fig.5 Tuner Amp Unit C - Attention of removing (Fig.6) Don't remove this screws excluding the dismantlement of the CD Mechanism Module. D Fig.6 E F DEH-34UB/XNUC 5 6 7 8 23 1 2 3 4 - Disassembling the Panel Part (Fig.7, 8) A 1. Remove the arm while bending the rib of the panel upward. B Fig.7 2. Press the upside hook and the bottom side hook of the button at the same time, and pull out the button. C Fig.8 - Assembling the Panel Part (Fig.9, 10, 11) 1. Attach the button from the front side of the panel. D E Fig.9 2. Attach the spring to the arm as shown in the figure. The bended tip of the spring is set to this side. F Hitch the spring to the groove. 24 Fig.10 DEH-34UB/XNUC 1 2 3 4 5 6 7 8 3. Fit the spring in the groove at the position shown in the figure. A 4. Fit the boss on the lower side of the arm in the lower hole of the panel, and then warp the rib on the panel in the direction shown in the figure and fit the boss of the arm in the panel. B Fig.11 C D E F DEH-34UB/XNUC 5 6 7 8 25 1 2 3 4 How to carry the mecha unit 1. Hold the designated points (shown with dashed lines) of the upper chassis and the front/rear bracket. 2. Be careful not to hold the solid line portions or the CRG mecha part or insert foreign substances, to prevent distortion. 3. When holding the sides of the upper chassis, do not apply excessive force to prevent distortion. (Approx. 8N or less) A Handling OK B Handling NG C D E F 26 DEH-34UB/XNUC 1 2 3 4 5 6 7 8 How to remove the PU unit 1. Create an empty-clamp state according to “How to create empty clamp state (motor drive)”. 2. Hook the feeding screw biasing spring to a tentative hooking portion (Fig 2b). Be careful not to get injured by the spring edge. 3. Hold the PU at the position A as shown in Fig 1. Slide the PU as far as possible toward the holder in the feeding screw so that a joint on the outer end of the feeding screw is loosened. 4. As shown in Fig 3, move the rear end of the feeding screw laterally and then upward, to remove it from the outer holder. 5. Lift the PU unit to disengage it from Part B of the chassis (Fig 4), and remove the PU unit. (Cautions) When re-installing the PU, be sure to first nip the chassis and the PU unit (Fig 4) at the position B. Also, make sure to fully hook the feeding screw biasing spring (Fig 2a). Please follow the service manual for adjustment of the PU unit after the re-installation. Slide toward inner circumference Fig 2a A Fig 2b B Fig 1 Fully-hooked state Tentatively-hooked state C B Fig 3 The spring is below a resin flange and is built inside the sheet metal bending. A Fig 4 D Outer holder Rear end of feeding screw [Incorrect built-in state] The chassis is not nipped between the PU case and the PU rack. Normal built-in state E F DEH-34UB/XNUC 5 6 7 8 27 1 2 3 4 8. EACH SETTING AND ADJUSTMENT 8.1 CD ADJUSTMENT A 1) Cautions on adjustments In this product the single voltage (3.3 V) is used for the regulator. The reference voltage is the REFO1 (1.65 V) instead of the GND. If you should mistakenly short the REFO1 with the GND during adjustment, accurate voltage will not be obtained, and the servo’s misoperation will apply excessive shock to the pickup. To avoid such problems: a. Do not mix up the REFO1 with the GND when connecting the (-) probe of measuring instruments. Especially on an oscilloscope, avoid connecting the (-) probe for CH1 to the GND. b. In many cases, measuring instruments have the same potential as that for the (-) probe. Be sure to set the measuring instruments to the floating state. c. If you have mistakenly connected the REFO1 to the GND, turn off the regulator or the power immediately. B Before mounting and removing filters or leads for adjustment, be sure to turn off the regulator. For stable circuit operation, keep the mechanism operating for about one minute or more after the regulator is turned on. C 2) Test mode This mode is used to adjust the CD mechanism module. To enter the test mode. [4] + [6] -> BUP + ACC ON To exit from the test mode. Turn off the ACC and back up. Notes: a. During ejection, do not press any other keys than the EJECT key until the loaded disc is ejected. b. If you have pressed the (→) key or (←) key during focus search, turn off the power immediately to protect the actuator from damage caused by the lens stuck. c. For the TR jump modes except 100TR, the track jump operation will continue even if the key is released. d. For the CRG move and 100TR jump modes, the tracking loop will be closed at the same time when the key is released. e. When the power is turned off and on, the jump mode is reset to the single TR (91), the RF amp gain is set to 0 dB, and the auto-adjustment values are reset to the default settings. In the test mode, any software protections will not work. Avoid applying any mechanical or electrical shock to the mechanism during adjustment. The RFAGC and RFO signals with a wide frequency range are easy to oscillate. When observing the signals, insert a resistor of 1k ohms in series. The load and eject operation is not guarantied with the mechanism upside down. If the mechanism is blocked due to mistaken eject operation, reset the product or turn off and on the ACC to restore it. D E F 28 DEH-34UB/XNUC 1 2 3 4 5 6 7 8 8.2 CHECKING THE GRATING AFTER CHANGING THE PICKUP UNIT A Note : The grating angle of the PU unit cannot be adjusted after the PU unit is changed. The PU unit in the CD mechanism module is adjusted on the production line to match the CD mechanism module and is thus the best adjusted PU unit for the CD mechanism module. Changing the PU unit is thus best considered as a last resort. However, if the PU unit must be changed, the grating should be checked using the procedure below. Purpose : To check that the grating is within an acceptable range when the PU unit is changed. Symptoms of Mal-adjustment : If the grating is off by a large amount symptoms such as being unable to close tracking, being unable to perform track search operations, or taking a long time for track searching. Method : Measuring Equipment Measuring Points Disc Mode B Oscilloscope, Two L.P.F. E, F, REFO1 TCD-782 TEST MODE CD CORE UNIT C L.P.F. F E E Xch Oscilloscope 390 pF VREF REFO1 Ych 100 kohm F 100 kohm VREF 390 pF D L.P.F. Checking Procedure 1. In test mode, load the disc and switch the 3 V regulator on. 2. Using the right and left buttons, move the PU unit to the innermost track. 3. Press key 3 to close focus, the display should read "91". Press key 2 to implement the tracking balance adjustment the display should now read "81". Press key 3. The display will change, returning to "81" on the fourth press. 4. As shown in the diagram above, monitor the LPF outputs using the oscilloscope and check that the phase difference is within 75 . Refer to the photographs supplied to determine the phase angle. 5. If the phase difference is determined to be greater than 75 try changing the PU unit to see if there is any improvement. If, after trying this a number of times, the grating angle does not become less than 75 then the mechanism should be judged to be at fault. Note Because of eccentricity in the disc and a slight misalignment of the clamping center the grating waveform may be seen to "wobble" ( the phase difference changes as the disc rotates). The angle specified above indicates the average angle. Hint Reloading the disc changes the clamp position and may decrease the "wobble". E F DEH-34UB/XNUC 5 6 7 8 29 1 2 Grating waveform 3 4 Ech -> Xch 20 mV/div, AC Fch -> Ych 20 mV/div, AC A 0 degrees 30 degrees 45 degrees 60 degrees 75 degrees 90 degrees B C D E F 30 DEH-34UB/XNUC 1 2 3 4 5 6 7 8 8.3 PCL OUTPUT CONFIRMATION A - PCL output With the TESTIN (22 pin) status of IC601 to be “H”, it is shifted to PCL Output Test mode after reset started. Check that square wave of 600.0 kHz is output from PCL (8 Pin) of IC601. If clock signal is out of this range, this resonator (X602) must be changed for a new one. B C D E F DEH-34UB/XNUC 5 6 7 8 31 1 2 3 4 9. EXPLODED VIEWS AND PARTS LIST NOTES : Parts marked by " * " are generally unavailable because they are not in our Master Spare Parts List. The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. Screw adjacent to mark on the product are used for disassembly. For the applying amount of lubricants or glue, follow the instructions in this manual. (In the case of no amount instructions,apply as you think it appropriate.) A " 9.1 PACKING 34UC B Tape C EW5 34UC 34UC 34UC D EW5 E F 32 DEH-34UB/XNUC 1 2 3 4 5 6 7 8 PACKING SECTION PARTS LIST Mark No. * * * Description DEH-34UB/ XNUC DEH-3400UB/ DEH-3400UB/ DEH-3450UB/ DEH-3450UB/ DEH-3490UB/ XNUC XNEW5 XNES XNES1 XNID 1 2 3 4 5 Polyethylene Bag Protector Protector Cord Assy Accessory Assy CEG1173 CHP4103 CHP4104 QDP3013 QEA3008 CEG1173 QHP3016 QHP3016 QDP3013 QEA3008 QEG3001 QHP3016 QHP3016 QDP3012 Not used QEG3001 QHP3016 QHP3016 QDP3013 QEA3009 QEG3001 QHP3016 QHP3016 QDP3013 QEA3009 QEG3001 QHP3016 QHP3016 QDP3013 QEA3009 6 7 8 9 10 Screw Polyethylene Bag Screw Handle Screw BPZ20P060FTC CEG1160 CRZ50P090FTC QNC3021 TRZ50P080FTC BPZ20P060FTC CEG1160 CRZ50P090FTC QNC3021 TRZ50P080FTC Not used Not used Not used QNC3021 Not used Not used CEG1160 Not used QNC3021 TRZ50P080FTC Not used CEG1160 Not used QNC3021 TRZ50P080FTC Not used CEG1160 Not used QNC3021 TRZ50P080FTC 11 12 13 14 15-1 Unit Box Contain Box Card Type RC Unit Case Assy Owner's Manual QHG3145 QHL3145 QXE1047 Not used QRD3099 QHG3143 QHL3143 QXE1047 Not used QRD3099 QHG3139 QHL3139 Not used QXA3129 QRD3098 QHG3140 QHL3140 QXE1047 QXA3129 QRD3100 QHG3142 QHL3142 QXE1047 QXA3129 QRD3100 QHG3146 QHL3146 QXE1047 QXA3129 QRB3195 QRY3001 Not used QRY3001 Not used CRY1316 Not used Not used Not used CRY1250 CRY1251 CRY1304 CRY1305 15-2 Warranty Card 15-3 Service Network A B Owner's Manual,Installation Manual Part No. Language C QRD3099 English, French, Spanish(Espanol) QRD3098 English, French, Italian, Spanish(Espanol), German, Dutch, Russian QRD3100 English, Spanish(Espanol), Portuguese(B), Traditional Chinese, Arabic, Persian QRB3195 English D E F DEH-34UB/XNUC 5 6 7 8 33 1 2 3 4 9.2 EXTERIOR A EW5 B B A C D A E A EW5 F 34 DEH-34UB/XNUC 1 2 3 4 5 6 7 8 (1) EXTERIOR SECTION PARTS LIST Mark No. * Mark No. Part No. Description Part No. 25 Screw BPZ20P100FTC BSZ26P080FTC 26 Spring CBH2210 Screw BSZ26P120FTC 27 Sheet CNN3494 Seal See Contrast table (2) 28 Knob Unit CXE3692 29 Spring YBL5010 30 Button(EJECT) QAC3066 1 Screw ASZ26P050FTC 2 Screw BSZ26P060FTC 3 Screw 4 5 6 Spring QBH3001 7 Cover QNM3029 8 Panel QNS3126 31 Button(LEFT) QAC3068 9 Arm QNV3025 32 Button(RIGHT) QAC3069 10 Button QNV3026 33 Button(1-6, -) QAC3070 34 Button(DETACH) QAC3071 35 Button(LIST, SRC, COLOR, RETURN, BAND) 11 CD Mechanism Module(S11.6) CXK5804 12 Cable A QAC3073 B QDE3021 13 Cord Assy See Contrast table (2) 36 Cover QNS3226 14 Case QNB3002 37 Lighting Conductor QNV3039 15 Holder QNC3020 38 Contact Rubber QNV3041 39 Segment LCD(V1801) CAW2018 40 Holder QNC3031 QNV3040 16 > Description Panel QNS3127 17 Tuner Amp Unit See Contrast table (2) 18 Screw BPZ26P080FTC 41 Lighting Conductor 19 Screw BSZ26P060FTC 42 Rubber Connector QNV3045 20 Screw BSZ26P120FTC 43 Grille Unit See Contrast table (2) 44 Door QAT3004 45 Card type RC Unit See Contrast table (2) 21 Holder See Contrast table (2) 22 Heat Sink QNR3002 C 23 Fuse(10 A) YEK5001 46 Cover See Contrast table (2) 24 Detach Grille Assy See Contrast table (2) 47 Label See Contrast table (2) (2) CONTRAST TABLE DEH-34UB/XNUC, DEH-3400UB/XNUC, DEH-3400UB/XNEW5, DEH-3450UB/XNES, DEH-3450UB/XNES1 and DEH-3490UB/XNID are constructed the same except for the following: Mark No. * Description DEH-34UB/ XNUC DEH-3400UB/ DEH-3400UB/ DEH-3450UB/ DEH-3450UB/ DEH-3490UB/ XNUC XNEW5 XNES XNES1 XNID 5 13 17 21 24 Seal Cord Assy Tuner Amp Unit Holder Detach Grille Assy CAN3984 QDP3013 QWM3310 QNC3033 QXA3474 Not used QDP3013 QWM3310 QNC3033 QXA3473 Not used QDP3012 QWM3309 QNC3032 QXA3472 Not used QDP3013 QWM3311 QNC3033 QXA3475 Not used QDP3013 QWM3311 QNC3033 QXA3475 Not used QDP3013 QWM3311 QNC3033 QXA3476 43 45 46 47 Grille Unit Card type RC Unit Cover Label QXA3424 QXE1047 CNS7068 Not used QXA3423 QXE1047 CNS7068 Not used QXA3422 Not used Not used Not used QXA3425 QXE1047 CNS7068 Not used QXA3425 QXE1047 CNS7068 Not used QXA3426 QXE1047 CNS7068 CNN3533 D E F DEH-34UB/XNUC 5 6 7 8 35 1 2 3 4 9.3 CD MECHANISM MODULE A A B (A) (B) B (A) (B) C (A) (A) B C C (A) D (A) (A) D (A) (B) (A) (B) E A C (A) (A) : GEM1024 F (A) 36 (B) : GEM1043 DEH-34UB/XNUC 1 2 3 4 5 6 7 8 CD MECHANISM MODULE SECTION PARTS LIST Mark No. Description Mark No. Part No. Description Part No. 50 Damper CNW1198 CBA1835 51 Arm CNW1726 Washer CBF1038 52 Motor Unit(M2)(LOAD/CRG) CXC4026 Spring CBH3010 53 Screw Unit CXC8894 54 Arm Assy CXE5027 55 Washer CBF1037 CBF1038 1 ..... 2 Screw BSZ20P040FTC 3 Screw(M2 x 4) 4 5 6 Spring CBH2855 7 Spring CBH2856 8 Spring CBH2860 56 Washer 9 Screw BSZ26P060FTC 57 Arm CND6242 10 Spring CBH3011 58 Collar CNW2444 59 Roller CNW1196 11 Coil Spring CBH3095 60 Gear Unit CXC8893 12 Spring CBH3014 13 Spring CBH3015 61 Washer YE15FTC 14 Spring CBH3016 62 Chassis Unit CXE4528 15 Spring CBH3017 63 Motor Unit(M1)(SPDL) CXE2273 64 Screw JFZ20P025FTC 65 Screw JGZ17P022FTC 16 Spring CBH3086 CBH3019 17 Spring 18 ..... 66 Screw EBA1028 19 Leaf Spring CBL1824 67 CD Core Unit (S11.6STD) CWX4023 20 Pickup Unit(P10.6)(Service) CXX3556 68 Chassis CNA3181 A B C 21 Bracket CND4553 22 Arm CND4555 23 Bracket CND6127 24 Bracket CND5710 25 Lever CND5398 26 Sheet CNN3678 27 Rack CNV8342 28 Guide CNW2240 29 Roller CNW1172 30 Holder CNW1195 31 Arm CNW2241 32 Roller CNW1175 33 ..... 34 Arm CNW1177 35 Arm CNW1178 36 Gear CNW1180 37 Gear CNW1181 38 ..... 39 Gear CNW1183 40 Rack CNW1184 41 Gear CNW1185 42 Gear CNW1186 43 Gear CNW1187 44 Gear CNW2287 45 Clamper CNW1190 46 Arm CNW1192 47 Holder CNW1193 48 Holder CNW1194 49 Damper CNW1197 D E F DEH-34UB/XNUC 5 6 7 8 37 1 2 3 4 10. SCHEMATIC DIAGRAM 10.1 TUNER AMP UNIT (GUIDE PAGE) A Note: When ordering service parts, be sure to refer to " EXPLODED VIEWS AND PARTS LIST" or "ELECTRICAL PARTS LIST". C441 CDSTBY 122 NM CDWAIT 123 100k R601 16 WAIT 15 PGND 13 LRCK 14 GND GND 11 DATA 12 BCLK 10 SDA VDD 9 SKIP RESET 8 7 PGND WAIT R716 220 LRCK BCLK DATA DGND1 SDA VDD4 SKIP RESET PCM1753DBQ 14 15 16 13 MD DGND 12 NC ZEROL/NA 6 ZEROR/ZEROA 11 VCC 7 VCOM 10 VOUTL 8 AGND 9 VOUTR 5 MC SCK ML LRCK 4 IC231 DATA BCK C233 C232 0.01u/16 CCG1192-A 10u 1000p/50 C239 BCK LRCK DATA SCK SCK ML MC MD MC MD DATA BCK CDDATAIN LRCK CDSCKIN CDLRCKIN CDSKIP CDWAIT CDLRCKIN CDSCKIN CDDATAIN except C 10p/50 6 7 ASEBRK TDO TDI 3 2 1 79 AUDIO_X2 78 TCK TMS 77 TDI 76 TDO ASEBRKAK/ASEBRK 75 TRST 74 TCK TMS R618 0.1u/10 80 AUDIO_X1 VSS7 PVCC6 81 82 VCC4 AUDIO_XOUT C620 0.1u/10 C619 83 84 R617 220 NM R616 85 CDSKIP DACBSCK NM 86 100 R614 87 DACDATA DACBDATA 88 NM R619 8 C617 C615 C613 100 R611 R613 89 PVCC7 DACLRCK 100 0.1u/10 0.1u/10 R609 C612 90 91 93 92 VSS8 VCC5 CADATAIN DACSCK C609 94 96 CDSCKIN CDLRCKIN 95 NM R634 MISO TUNPCK 99 RDS_INT 98 TUNPDI 97 NC TUNPDO NM NM NM CE C607 0.1u/10 100 101 102 PVCC8 MOSI KYDT/TESTDI 35 33 0.1u/10 34 PVCC4 CKIO VSS4 BTRX NMI BTTX VCK VCK 32 30 KYDT 31 29 C621 28 DPDT DPDT/TESTDO VDT 27 VDT VST VCC3 26 0.1u/10 C618 25 24 0.1u/10 VSS3 PVCC3 23 C616 TESIN 22 R615 100k TESTIN 21 MUTE /USBFLG SYNC 20 2.2k NM C614 VCC2 VSS2 /RDSLK USBCTL 19 17 18 16 C610 R610 R612 47k 6 ILM+B ROT1 DGND KYDT NM 1 BTRX 2.2k R803 ROT0 2.2k R808 2.2k KY RO ILM ROT1 4 SWVDD 3 2 ILMCLR R804 R814 5 ILMGND 3 3 R810 2.2k RO SWVD ILMG DGND C802 0.1u/16 USGND C803 0.1u/16 NM 7 ROT0 8.2 ILMCLR 2.2k C851 RGBDT/USBGND 2.2k R811 4.7k KYDT 8 R805 44 R812 R851 9 BTTX VST MUTE FLG SYNC USBCTL VDCONT BTRST TELIN SYSPW ICLR1 US5V 8.2k USBGND GRILLE GND The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. GND D GND USBGND ILM GND DEH-34UB/XNUC 2 2 1 NM 103 ANTPW DM DPDT2 R809 10 8.2 C810 220p/50 C811 220p/50 CN1821 14 DPDT AU AU R806 ICLR2 DM 13 12 11 AU L801 CTF1713-A 2 2 11 DP RGBCK/ILMCLR1 USB5V 100 100 D811 DZ2S068C B R817 R801 22k R815 D810 DZ2S068C 15 AUXG 100 22k 0.1u/16 DP NM AUXR R802 R816 D807 DZ2S068C AUXGND 16 SSE 2.2k SRC D806 NM 17 GND C808 GND NM : No Mount 1 3 150 150 R715 R714 NM NM NM R718 R719 R720 1k 2.2k R813 RGBDT R807 AUXL 2.2k D801 DZ2S068C AUXR R818 C812 1u/16 D802 DZ2S068C SOURCE 18 D805 DZ2S068C 19 GND NOTE : Symbol indicates a resistor. No differentiation is made between chip resistors and discrete resistors. Symbol indicates a capacitor. No differentiation is made between chip capacitors and discrete capacitors. 38 R712 DIM 20 AUXL D804 DZ2S068C 1u/16 DSENS RGBST/ILMCLR2 A DSENS C818 CKS6288 0.1u/16 C961 10k GND F 0.1u/10 1 NM R691 CN801 10k C969 R970 220p/50 10k R972 A GND 1k R968 5 D803 DZ2S068C R964 6 C809 0.1u/16 1 BTR C967 470p/50 D809 DZ2S068C 2 GND IN+2 7 NM U1OUT GND IN-2 GND SYS+B L962 NM 8 D808 3 P DSENS1 C801 NM U1IN 1k 47k NM R966 OUT2 IN+1 10k L961 4 VCC IN-1 R973 GND 5 220p/50 0 4 10u C962 NM 3 10k 2 OUT1 CCG1192-A C970 6 R969 10k 7 VCC PL BTL 1 C966 MIC1P R965 15 2 3 R604 47k 4 NC 7 144 6 SSENS ASENS 5 143 LPF C968 470p/50 47k MIC1N 8 MD BSENS 142 R508 10k NM VA891 C963 R962 8.2k 1u/10 9 MD_ 141 ASENS KEYD R967 10 DSENS FLG USBCTL IC961 NJM4558MD 1u/10 VSS RGBDT BTTESTMD SSENS KEYAD R961 SPKR VSS12 BSENS BTRST BTRX BTTX NM 11 ILMCLR2 BTTESTIN PVCC2 138 NM BTTESTIN 139 VDCONT 137 R641 14 RGBDT 13 136 SYNC A 0.1u/10 135 47k 0.1u/10 USB 47k C608 134 USB ROT0 R608 C603 SYNC KEYD2 R971 VSS CDRST U 4 R963 8.2k C964 C965 12 NM D961 SPKL CD_SDA U PVCC11 ILMCLR2 BT MOD GND GND 13 VSS 1k VR105C5R0AAA CN961 VKN1189 NRST_CPU VA892 VA893 W.REM&MIC E 1k R891 C605 ILMCLR1 KEYAD2 VA894 (W/R) R892 0.1u/10 133 GND MIC1N 104 ILMCLR1 KEYD ROT1 USBCTL MIC1PF 6 5 4 3 2 1 (RMIC) 105 ILMPW CRG03 GND JA891 YKS5035 106 132 VBUS C513 /OC BD2232G-G SWVDD ILMPW FLG EN US 131 5 GND US R5S7266ZD144FP VSS11 130 GND 1u/10 NM C510 3 0.1u/16 C891 0.1u/16 C892 KEYAD C511 1 3 2 1u/10 2 KEYD VOUT R IC601 NC PVCC10 129 BTTESTMD 140 VIN DACCS ROT0 RGBDT C512 1 USBA R607 NM R507 US CDWAIT 0.1u/10 51k R506 US USBA 2 220p/16 6 5 BD9008F US CDSTBY 3 PVCC1 4 NC 5 VSS1 DIMMER 6 VCC1 PCL 7 ANTPW SYSPW 8 PCL TELIN1 9 TELIN 10 BT RST ROM 11 ROM 12 RAM_MON RAM_MON RT INV EN/SYNC US SYSTEM MICRO CDRST CDSRQ C606 GND FB CPPWR VSS10 ROT1 GND 7 MOD PVCC9 0.1u/10 SW V NC CPRST KEYD 8 C506 0.015u/16 GND 128 A D502 8 VIN 127 TUNSDA TUNSCL CRG03 D503 IC510 JA892 CKS4124 0.1u/10 16.934MHz 2 2 CP_SDA CP_SCL 1 18k R505 4 C602 47k 3 PVIN 124 126 R602 2 GND D501 RB160L-40 62k C503 3.6k 1 1u/16 NM C505 IC501 NM 125 SWVDD5 USB&USB5V 12k R504 R605 10k R603 ipod CP C509 NM R503 R502 470 C502 R501 R561 CPRST GND 150 119 ML GND R713 118 121 16 USB5V GND W.REM 117 120 IC551 341S2162 L501 CTH1475-A 100 116 0.1u/10 CDSRQ C507 R557 4.7k 220 114 CDRST CP_SCL 22p/50 0.1u/10 R711 113 CP_SCL CPPW C508 2 R556 2.7k R710 L701 112 RF GND CP_SDA VSS9 /SSL 110 111 *2 VCC6 109 CD_SCL RSPCK CD_SDA CD_SCL TUNPCE1 108 NM 107 NM NM NM R414 NM CD_SDA GND TUNPCE2 L415 *2 R430 R415 R418 1000p/50 C447 C439 R417 1k 115 1 4 3 5 D C552 CDSKIP GND R416 CP_SDA 17 NC9 NC10 18 NC11 NC12 19 NC13 20 NC7 8 NC6 NC5 7 NC4 NC3 6 47k 0.1u/10 DGND NM 220u/6.3 9 6 VD C671 D601 RB551V-30 11 VSS I2C_SCL/SPI_SIMO 12 I2C_SDA/SPI_SOMI MODE0/SPI_CLK 13 VCC NC8 nRESET 14 NC2 MODE1/SPI_nSS NC1 15 10 47k NM X601 CSS1603-A 1 3 1 3 1 C611 0.1u/10 R671 10k R419 C440 10k R420 GND SO 2 SO C604 100 5 SCL CE# R562 47k C551 R551 0.1u/10 100 SCL 7 HOLD# 8 VDD 3 R672 M2R6TP_GND CPPW 4.7k R560 100 WP# C601 R559 CD_SCL VSS CPRST R558 GND 4 SI SCK 6 VDD3.3V NM C703 L671 CTF1786-A IC671 5 DGND R553 10k CDSTBY CDSRQ PEB011A8 *5 SI SCK KN601 C438 NM C436 C433 NM C430 IC671 PEB012A8 820 B.UP FLASH ROM *2 R231 D GND NM NM A,B NM C706 VDD3.3V NM 0 820 NM C702 C~F NM C705 R232 NM 8.2 Q551 LSA1576UB(QRS) R552 10k 220 NM R709 100k C701 R708 R721 220 1 R703 NM C704 2 *5 2.2u CCG1205 C442 L411 NM R428 4 /CDSTBY VD 3 SW5V CTF1786-A L410 8.2 RFGND L551 3 /CDSRQ 6 R707 NM C753 RKZ8.2KG(B2) 4 GND VDCONT NM C437 0.1u/10 C429 9p/50 C432 C431 C435 49 50 52 51 VCC-REF VDDIO1V2 VDDPLL1V2 VCCREG1V2 REG1V2 VREG3V3 RSTN RDSINT 31 VDIG 46 GND1V2 45 GPIO0 44 GPIO1 43 GPIO2 42 GPIO3 41 GPIO4 40 GPIO5 39 GPIO6 38 GPIO7 37 GPIO8 36 GND3V3 35 VDD3V3 34 I2CSCL I2CSDA 33 C455 R408 L409 *2 5 8 R427 *2 *2 RF GND 100k 100k NM NM C235 R717 47k R702 VDCONT L419 1/4W 1/4W DGND R410 R412 C434 *2 C427 DGND *2 6 RN4983 C234 CCG1192-A 10u DGND R701 R421 47 VDD_CORE 30 28 27 29 GNDSLINK AMMIXIN1 LNADEC2 AMMIXIN2 26 25 24 22 C422 0.1u/10 R433 21 LNAIN2 LNAOUT LNAIN R406 R431 NM NM L416 NM RF GND C454 1 820 CD/USB:+5.22 dBs NM PGND DAC L414 NM *2 NM C708 NM C709 GND DGND R429 NM 48 TEST C707 0.01u/16 L412 L413 32 1u/10 2 *2 *2 R434 C457 C423 0.01u/16 1M R405 C444 L417 NM C451 R413 C458 1M *2 LNADEC GNDLNA 18 17 C415 0.01u/16 0.1u/10 L406 R407 R403 L405 L418 L420 C421 C408 C443 20 RFGND 5 R754 AGND NM L407 750 KP2311E C406 GND 2 R753 R704 4.7k 3 GND1 X1 CSS1805-A C409 0.01u/16 16 10u 19 C404 0.1u/10 C405 15 C412 10u CCG1192-A RFGND C445 0.022u/16 0.1u/10 NM C456 A GND RFGND L403 CTF1786-A 0.1u/10 C419 C417 R402 RFGND X2 4 GND2 4 FMMIXDEC 5 FMMIXIN2 C413 FMPINDRV FMMIXIN1 FMPINDDEC 0.01u/16 6 GNDRF C414 7 TCAM 1u/10 8 VCCRF IC401 AGND C450 9 orRFGND CK_SEL TDA7706 NM 10 GNDVCO LFREF 11 LFREF C407 C410 LF1 12 LF1 13 VCCVCO PINDDEC 0.1u/10 0.01u/16 PINDIN C411 0.01u/16 14 TCAM2 L402 CTF1786-A 3 C446 RFGND NM 0.01u/16 C403 0.01u/16 6p/50 C402 1 2 L404 33p/50 L401 0.15u D402 220 C401 *2 C449 NM R401 D401 KP2311E NM X401 64 TVDAC 63 C416 TCFM 62 0.22u/16 PLLTEST 61 GND-PLL 60 VCC-PLL 59 VCC-ADC_DAC 58 DACOUTR 57 DACOUTL 56 GND-ADC_DAC C426 55 VREFDEC GND-REF 54 0.1u/10 OSCOUT OSCIN 53 R409 NM C448 36.48MHz 1 C420 RFGND C418 CCG1192-A P401 3 KN401 NM IMSA-6802-01Y900 R432 1 M2R6TP_GND C CTF1786-A L408 JA401 YKS5041 TUNGND 2 4 7 TUNL AGND 3 GND VDSENS TUNR C452 B Q752 C754 0.1u/10 D751 C751 CCG1192-A 47k 10u VD1 C424 4700p/25 C428 9p/50 TUNER CDSRQ Q751 2SD2396(K) C425 4700p/25 CTF1786-A ANTENNA CN701 NM C710 7.4V VD2 CDSTBY MECHA VD 2 1 CN701 VKN1192 FM(30%) -15 dB±2.5: -15.0 dBs AM(30%) -15 dB±2.5: -15.0 dBs FM(30%) -11 dB±2.5 (EW5): -11.0 dBs AM(30%) -11 dB±2.5 (EW5): -11.0 dBs Detailed page A-b C CD D~F CCG1205 0.1u NM NM 330 360 390 0 NM NM 0 NM NM 0.1u R751 NM NM 0.39uH NM 1.5uH 2.2uH NM 0.39uH 0.27uH NM C NM NM NM NM 1.5k 470 680 NM NM 0 NM 0.47u 0.1u NM A,B NM NM 1u 3p 1.5k 470 680 0 0 0 NM 0.47u 0.1u NM C432 C433 C457 C458 R403 R406 R408 R421 R431 R433 R434 C430 C431 C439 10k D~F 15p 22p 2p 0.01u 8p R752 Guide page C NM 100p 82p 0.01u NM NM NM 0.27uH CTF1389 22uH 47uH CTF1786 NM NM NM A,B NM 100p 82p NM NM 1u 10p 0.27uH CTF1389 22uH 47uH NM NM NM 68n C408 C421 C427 C443 C444 C452 C455 L404 L405 L406 L409 L416 L417 L418 L420 LNAOUT2 A-a A-b A-a *2 23 A-a Large size SCH diagram A-b 33 A-a 3 4 5 6 7 8 A A-b Selector input C302 0.47u/10 C306 0.47u/10 220 12MHz YSS5005-A 22k C255 100p/50 R255 3 100p/50 22k NM C259 1000p/50 NM C261 C260 100p/50 100p/50 R257 RN1910 SYSPW SW5V NM 1.2V C321 C320 C319 C318 10p/50 10p/50 10p/50 10p/50 C312 0.1u/16 NM C927 1000p/50 C923 1000p/50 1000u/16 C926 1 C921 0.1u/16 C922 4.7u CCG1201-A NM C918 CCG1201-A C924 4.7u 220u/6.3 C919 1000p/50 C920 R912 C929 220u/6.3 CCG1201-A C912 FL2 FR1 C931 0.1u/16 4.7k R933 47k R932 SWVDD B.UP Q931 LSC4081UB(QRS) R933 4.7k 47k FUSE YEK5001 (10A) 16 GND 17 > 15 B.UP 14 BREM 13 ACC 12 A.ANT 9 8 7 TEL RRRL- 6 RR+ 5 RL+ 4 FR- 3 FL- 2 FR+ 1 FL+ E 10k Vcc NM Q873 LTC143EUB 8 B2 5 2 B1 7 C1 6 1 E1 NM ANTPW 6 OUT GND6 GND1 GND5 GND2 GND4 GND3 IN VDD NM D951 CRG03 1 2 OUTY TC7SET08FUS1 2.2u 3 15k 1SS301 GND R952 1/16W 4.7k 9 3 C2 DIAG 1k only C 10k GND 4 5 A DEH-34UB/XNUC NM B DEH-3400UB/XNUC 5 C DEH-3400UB/XNEW5 4 D DEH-3450UB/XNES INA GND L941 D941 Q953 LTC114EUB Q951 D952 10 0 R951 1/10W NM IC951 NM 1.2k R876 R875 CRG03 6 NM NM ANTPW INB TELIN R942 F E DEH-3450UB/XNES1 F DEH-3490UB/XNID GND DEH-34UB/XNUC 5 CKM1586 FR2 D931 HZU7L(A1) Q952 2SB1731-TLB C951 NM 5 2 1 R873 4 3 1.5k NM NM R885 R874 R877 R884 NM NM D871 R879 R878 Q872 E2 4 C817 SWVDD JA901 18 *3 0.1u/10 NM C852 NM 4.7k R851 C851 GND D FL1 NM GND B.REM RL1 R941 GND 3 P-GND4 25 FM(30%):+20.1 dBs AM(30%):+20.1 dBs FM(30%) (EW5):+24.1 dBs AM(30%) (EW5):+24.1 dBs AUX:+36.3 dBs CD/USB:+36.3 dBs IC801 2 RR- 24 R943 ILM GND 1 MUTE 23 RR1 HZU7L(C3) TELIN ROT1 L851 RR+ 10 22k Q941 LSA1576UB(QRS) C952 8.2k DPDT ROT0 R810 2.2k 21 ACC 1SR154-400 A.ANT NM DPDT NM C871 NM 47k C873 2.2k VCC RL2 C Q871 NM R880 D872 R872 1 C872 0.1u/16 R871 ILMCLR1 FR- 20 11 ILM A,B,D~F GND R881 NM CRG03 R805 DM 8.2 ILMCLR2 P-GND3 19 RR2 ASENS DIM ILMPW BTRX NM D874 D873 CRG03 CRG03 CRG03 CRG03 8.2 FR+ TELIN 1k R882 D875 17 AANT R934 HZU7L(A1) AC-GND RFGND D931 22k RRIn FRIn 16 GND D912 *3 ASEN1 R931 AGND 15 BREM 1SR154-400 GND ASEN2 RLIn Q874 2SA1577(QR) R883 DP NM C917 4.7u CCG1201-A C911 C651 1u/10 NM C652 4.7u S-80827CNMC-B8M 1 R911 C925 NC1 220u/6.3 C913 VSS 4 4.7u CCG1201-A C915 VDD FLIn 12 BUP1 BUP3 D911 1SR154-400 NM C916 NM C928 NC2 1000p/50 C914 NM R651 OUT 11 D954 10 +BUP 11 VDDCONT VDDCNT 5 FL+ SVR 14.4V D902 8 VDD12 9 SWVDD SWVDD IC651 9 10 1SR154-400 6 SW5V 7 VDD VDD1 1k 1 P-GND1 PW CONNECT 600 uH 4 +B 5 SYS+B SYSB VDD3.3V R629 FL- 8 GND L901 CTH1432-A 2 1 GND1 GND2 D901 2 SYSPW 3 SW5VCNT +B USB GND VCC 7 NM IC912 BA49182-V12 1 BSENS BSENS 12p/50 NM KYDT D301 2 1 4 1 4 X602 IC REGULATOR BSENS SYSPW C633 C GND 2 33 MUTE GND RST D876 2.2k 10k RN4983 RESET AUXR AUXG 2.2k CRG03 6 CCG1192-A 5 1 RL+ 6 18 D302 CRG03 C632 GND STBY 5 22 4 10k C638 10k 2 CCG1205-A 2.2u CCH1732-A GND 3300u/16 MU1 10u C351 MUTE AC-GND C901 R353 Q351 3 12p/50 AUXL 3 3 47k CCG1205-A 2.2u GND C309 0.1u/16 4 14 A GND C311 C310 3 P-GND2 RL- 13 12 GND 2.2k 2.2k GND BUP2 SSENS R806 NM GND C317 0.47u/10 GND 1p/50 0.47u/10 C308 C315 0.47u/10 C307 R352 DP DM C313 100p/25 C305 0.47u/10 0.47u/10 C334 NM C331 NM C333 NM C332 NM 0.47u/10 C304 VBUS 100 ILMPW L801 CTF1713-A 2 2 11 NM except C IC301 PAL007E TAB 2 C314 NM 1 E1 C303 R351 1u/10 10k R632 R633 2 BTTX VCK KYDT DPDT VDT 5 GND DDCONGND 100p/50 R302 2 B1 C1 6 GND ASENS R807 R303 3 C2 B2 5 470 SYS+B USBA GND SW5V 47k B.UP 47k NM VDD3.3V R631 NM VDD1.2V D~F GND R809 2 STBY E2 4 R304 470 R333 470 R334 R332 470 R331 R630 A~C 47k 47k R620 R642 C621 0.1u/10 0.1u/10 C616 C618 0.1u/10 3 Q252 6 R258 NM NM NM C637 C635 47k R630 R631 47k C301 *1 100k VST 1 3 FL 1 10u/16 C316 VDSENS AGND C631 C629 36 35 34 33 10k R628 D602 RB751S-40 68 3 C810 220p/50 C811 220p/50 2 1 47k R621 NM C636 5 4 C634 6 3 TRST TDO TDI ASEBRK 73 0.1u/10 69 NM AVSS GND R808 2.2k PR 4 Q301 R301 NM GND C630 70 KEYAD *1 0.1u/10 PVCC4 CKIO VSS4 BTRX NMI BTTX VCK KYDT/TESTDI 71 67 VDSENS 66 NC 65 GND NC MODEL 64 MODELAD 63 USBUVSS C623 62 USBUVCC 0.1u/10 61 USBAVSS 60 C624 0.1u/10 USBAVCC 59 C625 0.1u/10 USBAPVCC 58 USBAPVSS R626 57 REFRIN 5.6k F% 56 USBDVSS C626 55 USBDVCC 0.1u/10 54 VBUS 53 DP 52 DM 51 USBDPVSS C627 50 ASEMD USBDPVCC 49 R622 0.1u/10 ASEMD 47k 48 USB_X2 47 R627 USB_X1 46 NM VSS6 C628 45 PVCC5 0.1u/10 44 VSS5 R623 43 XTAL NM R637 1.5k 42 EXTAL 41 MD_BOOT0 R624 47k 40 MD_CLK0 R625 NM 39 PLLVSS R636 38 RES 47k PLLVCC 37 32 DPDT/TESTDO NC AVREF 31 30 29 VDT 28 47k 7 8 R619 2 1 NM 79 AUDIO_X2 AUDIO_X1 78 TCK TMS 77 TDI 76 TDO ASEBRKAK/ASEBRK 75 TRST 74 TCK TMS R618 0.1u/10 PVCC6 81 VSS7 80 C620 0.1u/10 82 27 C622 72 AVCC VDD1.2V NM R640 D651 R803 NM except C 820 AMP SWVDD5 R804 PL KEYAD 0.1u/10 R811 4 RL FR RR FL except C 10p/50 C617 NM 220 C619 R616 R617 84 85 86 83 VCC4 CDSKIP DACBSCK AUDIO_XOUT VCC3 VSS3 VST PVCC3 24 26 25 23 CCG1201-A L602 CKB1056 *4 JA251 2 GND O 44 R812 R254 C254 4.7u FRch C RCAG 6 VDD3.3V NM 1 P/O FR NM R639 2 2 JA251 A,B,D~F CKB1099 2 P/O > P251 CEK1286 820 16.934MHz L601 FR *4 820 R253 CCG1201-A X601 CSS1603-A 1 3 1 3 GND R252 4.7u C253 4.7u 5 C252 CCG1201-A RR Set back chart R259 B.UP FLch 3A 1 R256 6 VDD3.3V 5 Q251 SW5V PRch FL PRE OUTPUT 1 MUTE 4 MC SCK VST B RL 820 CCG1201-A 4.7u VCK SYS+B R251 C251 PLch VDT 2 BTL TUNR AUXL BTR AUXR AUXG RCA C256 1k 2 GND GND 22k A GND NM GRILL 801 - 850 SWVDD5 851 - 870 ILMPW 871 - 890 W.REM&MIC 891 - 900 PW CONNECT 901 - 910 IC REG 911 - 930 ASENS 931 - 940 TELIN 941 - 950 A.ANT 951 - 960 BT MOD 961 - 990 FM(30%): -5.9 dBs AM(30%): -5.9 dBs FM(30%) (EW5): -1.9 dBs AM(30%) (EW5): -1.9 dBs AUX:+10.3 dBs CD/USB:+10.3 dBs RN1910 NM C214 C257 8 6 7 5 FM(30%): -5.9 dBs AM(30%): -5.9 dBs FM(30%) (EW5): -1.9 dBs AM(30%) (EW5): -1.9 dBs AUX:+10.3 dBs CD/USB:+10.3 dBs 4 3 1 R201 C213 100p/50 CCG1201-A 4.7u 10p/50 C215 10p/50 C203 C202 C201 CCG1192-A 10u NM E-VOL output 22k PML022A FM(30%): -10.9 dBs AM(30%): -10.9 dBs FM(30%) (EW5): -6.9 dBs AM(30%) (EW5): -6.9 dBs AUX:+5.3 dBs CD/USB:+5.3 dBs only C TUNER AMP UNIT REFERENCE AREA MAP EVOL 201 - 230 DAC 231 - 250 RCA 251 - 300 AMP 301 - 400 TUNER 401 - 500 USB&USB5V 501 - 550 I-POD 551 - 600 UCOM 601 - 650 RESET 651 - 670 FLASH ROM 671 - 690 DSENS 691 - 700 CD MECHA 701 - 750 MECHA VD 751 - 800 Selector output ROL TUL 1u/10 C211 C204 10p/50 A C258 13 20 18 19 23 21 4 IN4+_L IN4+_R 5 IN4-_L IN4-_R 6 POUT_L POUT_R 7 FRONT_L FRONT_R 8 REAR_L REAR_R 9 NC1 NC2 10 VCC STB 11 VREF CLK 12 GND DATA 22 24 1 IN1_L IC201 NM 1u/10 NM R206 C231 C233 C232 0.01u/16 L201 NM R205 CCG1192-A 10u 1000p/50 C239 BCK 1u/10 C212 820 LRCK DATA 1u/10 C207 C217 NM L231 CDSKIP 1u/10 C209 AGND R207 C237 R231 D GND C205 NM C238 1800p/50 E-VOL 1800p/50 PCM1753DBQ 14 15 13 MD DGND 12 NC ZEROL/NA 6 ZEROR/ZEROA 11 VCC 7 VCOM 10 VOUTL 8 AGND 9 VOUTR 5 SCK ML MC 4 IC231 LRCK DATA BCK 2 1 3 16 820 2 IN2_L LPF R232 TUNL NM IN2_R IN1_R C235 IN3_R C 3 IN3_L C234 CCG1192-A 10u FM(30%): -15.0 dBs AM(30%): -15.0 dBs FM(30%) (EW5): -11.0 dBs AM(30%) (EW5): -11.0 dBs AUX:+2.2 dBs CD/USB:+5.2 dBs ROR NM 14 1u/10 C216 15 1u/10 C206 16 C208 17 1u/10 TUR 5.22 dBs C210 6 7 A 8 39 7 2 1 03-A 3 3 820 R231 820 R232 16.934MHz TCK C238 VDD3.3V B.UP C630 0.1u/10 C626 5.6k F% R626 0.1u/10 C625 D602 0.1u/10 0.1u/10 C623 GND RB751S-40 C624 MODEL 0.1u/10 70 69 0.1u/10 C622 71 KEYAD 68 AVSS 67 VDSENS 66 NC 65 NC 64 MODELAD 63 USBUVSS 62 USBUVCC 61 USBAVSS 60 USBAVCC 59 USBAPVCC 58 USBAPVSS 57 REFRIN 56 USBDVSS 55 USBDVCC 54 VBUS 53 DP 52 DM 51 AVREF NC AVCC 72 AGND LPF SW5V NM L231 C237 1800p/50 1800p/50 NM USBA GND NM NM R206 R205 BTR *1 1u/10 1u/10 C209 C207 AGND C217 NM 1u/10 C205 E-VOL NM C216 GND D~F A~C *1 GND ROR 17 TUR TUL C211 NM AUXL 22 47k NM R630 NM NM R640 L602 NM NM R639 L601 20 21 19 VDD3.3V NM 47k R631 100 R633 GND SYS+B NM C214 NM L201 VDD1.2V 1u/10 C235 8 C232 0.01u/16 TMS 1000p/50 6 ZEROR/ZEROA 11 VCC VCOM 10 VOUTL AGND 9 VOUTR 0.1u/10 NM 47k PCM1753DBQ C233 8 R619 TDI NM R618 CCG1192-A 10u 7 2 1 TDO 6 TRST 3 80 AUDIO_X1 79 AUDIO_X2 78 TCK TMS 77 TDI 76 TDO ASEBRKAK/ASEBRK 75 TRST 74 ASEBRK 5 4 C231 47k R621 R207 AUXG 10k C212 16 15 10p/50 C204 9 NC1 C234 CCG1192-A 10u R630 R631 73 AUXR 47k 47k BTL C634 C635 TUNR NM C636 NM C637 R632 IC201 1u/10 NM NM 10k only C GND 5 6 4 1 Q351 10k R351 GND C306 0.47u/10 C302 220 R353 C308 C307 0.47u/10 0.47u/10 C303 C304 C305 0.47u/10 C301 NM R301 FM(30%): -5.9 dBs AM(30%): -5.9 dBs FM(30%) (EW5): -1.9 dBs AM(30%) (EW5): -1.9 dBs AUX:+10.3 dBs CD/USB:+10.3 dBs E-VOL output FM(30%): -10.9 dBs AM(30%): -10.9 dBs FM(30%) (EW5): -6.9 dBs AM(30%) (EW5): -6.9 dBs AUX:+5.3 dBs CD/USB:+5.3 dBs Selector output FM(30%): -15.0 dBs AM(30%): -15.0 dBs FM(30%) (EW5): -11.0 dBs AM(30%) (EW5): -11.0 dBs AUX:+2.2 dBs CD/USB:+5.2 dBs Selector input 2 1k DM 470 3 MUTE VST VCK VDT C331 NM DP VBUS VDSENS KEYAD A GND CCG1201-A 4.7u 14 CLK 13 12 GND DATA C213 23 TUNL PML022A 100p/50 18 C201 CCG1192-A 10u VDD1.2V 7 2 NC2 10p/50 C215 ROL C202 B.UP 6 3 STB 10 VCC VDD3.3V 8 R201 1 11 VREF 10p/50 C203 SW5V 5 4 SYS+B 24 C638 FL R331 1 IN1_L IN1_R 2 IN2_L IN2_R 3 IN3_L IN3_R 4 IN4+_L IN4+_R 5 IN4-_L IN4-_R 6 POUT_L POUT_R 7 FRONT_L FRONT_R 8 REAR_L REAR_R 1u/10 FR 470 R332 RL R333 470 RR 470 R334 1u/10 NM C332 1u/10 NM C333 C206 NM C334 1u/10 10k C208 R352 2 B1 1 E1 C1 6 MU1 0.47u/10 0.47u/10 0.47u/10 0.47u/10 3 C2 B2 5 NM Q301 CCG1201-A C310 CCH1732-A GND 3300u/16 C901 CCG1205-A 2.2u GND C309 0.1u/16 GND NM R302 820 R254 820 AMP C254 4.7u CCG1201-A C253 4.7u R252 C252 CCG1201-A 820 R253 820 4.7u R251 MUTE C251 CCG1201-A 4.7u E2 4 FRch FLch PRch PLch RCA 1 Q251 R303 R304 C210 CCG1192-A 2 6 1 Q252 6 10k 47k A-a A-b 10u C351 3 5 2 5 4 3 A C311 GND NM 10u/16 C316 C313 GND except C D302 CRG03 GND 1 2 NM A GND STBY AC-GND GND DDCONGND FR FL PR PL RCAG P251 CEK1286 R259 1 P/O MUTE RRP-GND4 22 23 24 25 RR+ 21 B.REM FR- P-GND3 VCC 20 FR+ 18 19 17 RRIn FRIn AC-GND 16 15 AGND 14 13 RLIn 11 12 FL+ SVR FLIn 9 10 FLP-GND1 8 RL+ VCC 7 6 STBY P-GND2 RL- IC301 PAL007E TAB 5 4 3 2 1 GND 4 5 6 2 1 3 except C CKB1056 *4 JA251 C JA251 2 P/O A,B,D~F CKB1099 *4 FR FL Set back chart RR RL > 3A FM(30%): -5.9 dBs AM(30%): -5.9 dBs FM(30%) (EW5): -1.9 dBs AM(30%) (EW5): -1.9 dBs AUX:+10.3 dBs CD/USB:+10.3 dBs GRILL 801 - 850 SWVDD5 851 - 870 ILMPW 871 - 890 W.REM&MIC 891 - 900 PW CONNECT 901 - 910 IC REG 911 - 930 ASENS 931 - 940 TELIN 941 - 950 A.ANT 951 - 960 BT MOD 961 - 990 TUNER AMP UNIT REFERENCE AREA MAP EVOL 201 - 230 DAC 231 - 250 RCA 251 - 300 AMP 301 - 400 TUNER 401 - 500 USB&USB5V 501 - 550 I-POD 551 - 600 UCOM 601 - 650 RESET 651 - 670 FLASH ROM 671 - 690 DSENS 691 - 700 CD MECHA 701 - 750 MECHA VD 751 - 800 CCG1205-A 2.2u 4 A-b 01 22k 100p/50 RN1910 RN1910 G03 R258 C314 C317 C315 4 12 u/16 22k R256 R257 R255 22k 22k C255 C256 C257 100p/50 100p/50 100p/50 1p/50 3 100p/25 DEH-34UB/XNUC C258 2 100p/50 1 C318 40 NM F C261 E C319 D 3 C321 PRE OUTPUT NM C259 B C260 C 2 C320 A 1000p/50 1 4 R628 29 KYDT/TESTDI 3 3 A 2 2 KYDT 2.2k REFRIN 51 52 53 54 55 56 57 58 0.1u/10 C626 DP AUXR AUXG AUXL SSENS 8 A-b DPDT DPDT SWVDD NM D875 R881 NM D874 D873 NM R882 2 CRG03 CRG03 CRG03 CRG03 CRG03 D876 R883 ILMPW 1k R629 12p/50 C632 USBA GND GND GND INA INB OUTY Vcc IC801 TC7SET08FUS1 3 2 1 ILM GND USB GND 12p/50 C633 4 5 100k NM R651 D651 Q871 NM Q874 2SA1577(QR) Q873 LTC143EUB GND RST RESET 1u/10 VSS VDD OUT NC1 NC2 4 5 VDD1.2 4 5 6 3 2 1 NM Q872 NM R873 S-80827CNMC-B8M 3 2 1 IC651 100 R633 B.UP B.UP 0 R875 DM DP VBUS ANTPW C1 6 B2 5 E2 4 TELIN ASENS SWVDD5 SYSPW BSENS MUTE 2 B1 3 C2 1 E1 NM ANTPW Q951 220u/6.3 C913 ASEN2 6 7 8 9 10 ASEN1 OUT IN NM 5 4 3 2 1 GND A-a A-b VDD GND4 GND3 GND5 GND2 GND6 GND1 DIAG NM IC951 C951 D931 HZU7L(A1) *3 6 5 4 MUTE RN4983 Q351 IC REGULATOR R931 22k C331 GND 1 2 3 10k R351 GND D951 CRG03 GND GND GND GND MU1 C A,B,D~F 1k 12 GND 10 +BUP 11 VDDCONT 8 VDD12 9 SWVDD 6 SW5V 7 VDD 4 +B 5 SYS+B 2 SYSPW 3 SW5VCNT IC912 BA49182-V12 1 BSENS 1k R941 22k Q941 LSA1576UB(QRS) R942 HZU7L(C3) D931 HZU7L(A1) RFGND 1SR154-400 D912 D911 1SR154-400 VDDCNT BUP2 SWVDD 1.2V VDD1 SW5V SYSB +B SYSPW BSENS ASENS R934 NM 10k R952 1/16W Q952 2SB1731-TLB A.ANT 220 R353 GND 1SS301 D941 47k R933 4.7k *3 CCH1732-A GND 3300u/16 C901 2.2u GND C309 0.1u/16 2.2u SW5V SWVDD ILMPW C315 D302 CRG03 D301 CRG03 2.2u L941 F DEH-3490UB/XNID E DEH-3450UB/XNES1 D DEH-3450UB/XNES C DEH-3400UB/XNEW5 B DEH-3400UB/XNUC A DEH-34UB/XNUC only C 15k R943 TELIN FM(30%):+20.1 dBs AM(30%):+20.1 dBs FM(30%) (EW5):+24.1 dBs AM(30%) (EW5):+24.1 dBs AUX:+36.3 dBs CD/USB:+36.3 dBs FL1 FR1 FL2 FR2 RL1 RR1 RL2 RR2 TELIN AANT ACC BUP1 BUP3 D954 FLFR+ FL+ 4 3 2 1 RR+ 5 FR- RL- RL+ 6 RR7 TEL 9 8 10 11 ILM 12 A.ANT 13 ACC 14 BREM 15 B.UP > FUSE CKM1586 JA901 YEK5001 17 (10A) 16 GND 18 PW CONNECT NM BREM GND 24 D902 14.4V 23 1SR154-400 1SR154-400 L901 CTH1432-A 2 1 GND1 GND2 D901 600 uH GND 100p/2 GND RR- 22 B.REM MUTE P-GND4 21 25 FRVCC RR+ P-GND3 20 FR+ 18 19 17 7 GND NM L851 ROT1 ROT0 KYDT ILMCLR1 C629 0.1u/10 GND 5.6k F% R626 0.1u/10 0.1u/10 C624 C625 VDD3.3V 59 SYS+B C928 60 C627 50 ASEMD USBDPVCC 49 R622 0.1u/10 ASEMD 47k 48 USB_X2 47 R627 USB_X1 46 NM VSS6 C628 45 PVCC5 0.1u/10 44 VSS5 R623 43 XTAL R637 NM 1.5k 42 EXTAL 41 MD_BOOT0 R624 47k 40 MD_CLK0 R625 NM 39 PLLVSS R636 38 RES 47k PLLVCC 37 USBDPVSS DM DP VBUS USBDVCC DM 8.2 ILMCLR2 R805 8.2 R806 R807 32 C621 VCK 30 VCK USBDVSS 35 BTRX 36 R642 PVCC4 CKIO VSS4 BTRX NMI 33 4.7k USBAPVSS 47k R620 BTTX 31 BTTX R851 10u C351 1000u/16 C926 USBAVCC C872 0.1u/10 C851 NM YSS5005-A C312 0.1u/16 USBAVSS R872 1 33 4 X602 C631 47k C873 34 NM 1 C318 10p/50 USBAPVCC NM 47k C852 0.1u/16 R871 R632 C651 2 1 NM R878 10k 1u/10 4 NM NM C871 NM NM C925 Q931 LSC4081UB(QRS) 12MHz R884 NM NM D871 R879 10k 1000p/50 R911 C914 4.7u 1 C929 CCG1201-A C915 220u/6.3 NM C916 R932 1 4.7u CCG1201-A C638 R877 4.7u CCG1201-A C912 47k 10k C921 C931 C319 10p/50 C333 NM C918 R352 0.1u/16 C922 0.1u/16 CCG1192-A 1000p/50 C923 C320 10p/50 C332 NM C917 4.7u CCG1201-A C911 C952 1000p/50 C321 10p/50 C334 4.7u CCG1201-A C924 R933 NM VDD3.3 DIM R876 C652 NM NM R885 R874 0.1u/10 R880 D872 NM C817 1.2k 1.5k 7 D952 DEH-34UB/XNUC NM 220u/6.3 C919 1000p/50 C920 R912 4.7k CRG03 6 4.7k C927 5 R951 1/10W 6 Q953 LTC114EUB 5 8 A B C D E 41 F NM KN401 C551 RFGND M2R6TP_GND 33p/50 C401 R401 D401 3 RFGND RFGND DEH-34UB/XNUC 4 NC7 8 NC6 NC5 7 NC4 NC3 6 9 10 R553 10k R552 10k NM L551 *2 L420 C443 IMSA-6802-01Y900 R432 *2 GND CTF1786-A L403 NM 1M C458 47k L404 RFGND 6p/50 CTF1786-A L402 1 JA401 YKS5041 C402 TUNGND 2 C456 R413 R551 NM 750 TUNER 0.1u/10 L401 0.15u 220 KP2311E P401 C403 0.01u/16 C404 C405 *2 L406 R403 10u CCG1192-A RFGND C445 0.022u/16 C412 C413 C432 C433 C457 C458 R403 R406 R408 R421 R431 R433 R434 C430 C431 C439 A,B NM NM 1u 3p 1.5k 470 680 0 0 0 NM 0.47u 0.1u NM 100 R560 17 NC9 NC10 18 NC11 NC12 19 NC13 20 C NM NM NM NM 1.5k 470 680 NM NM 0 NM 0.47u 0.1u NM D~F CCG1205 0.1u NM NM 330 360 390 0 NM NM 0 NM NM 0.1u AGND 3 2 1 NM C424 4700p/25 C425 4700p/25 1 ipod CP RFGND 0.01u/16 C415 16 15 *2 NM R561 NM NM C454 R434 C457 R562 DGND X2 GND1 X1 CSS1805-A 4 GND2 X401 36.48MHz FM(30%) -15 dB±2.5: -15.0 dBs AM(30%) -15 dB±2.5: -15.0 dBs FM(30%) -11 dB±2.5 (EW5): -11.0 dBs AM(30%) -11 dB±2.5 (EW5): -11.0 dBs NM NM 0.39uH NM 1.5uH 2.2uH NM 0.39uH 0.27uH NM C448 IC551 341S2162 100 R559 16 4.7k R558 Q551 LSA1576UB(QRS) L418 L405 C408 A GND 0.01u/16 4 FMMIXDEC 5 FMMIXIN2 FMPINDRV FMMIXIN1 FMPINDDEC 0.01u/16 6 GNDRF C414 7 TCAM 1u/10 8 VCCRF IC401 AGND 9 orRFGND C450 CK_SEL TDA7706 NM 10 GNDVCO LFREF 11 LFREF C407 C410 LF1 12 LF1 13 VCCVCO PINDDEC 0.1u/10 0.01u/16 PINDIN 14 TCAM2 C411 0.01u/16 C446 RFGND NM C409 0.01u/16 RF GND *2 *2 46 47 48 NM L410 GND1V2 45 GPIO0 44 GPIO1 43 GPIO2 42 GPIO3 41 GPIO4 40 GPIO5 39 GPIO6 38 GPIO7 37 GPIO8 36 GND3V3 35 VDD3V3 34 I2CSCL I2CSDA 33 VDD_CORE TEST C432 DGND R751 C441 L416 R421 L414 NM NM NM D502 RF GND *2 *2 DGND 0.1u/10 C440 NM 2.2u CCG1205 C442 *2 L412 L413 DGND R429 NM Q751 2SD2396(K) CPRST CP_SDA CP_SCL CPPW NM L419 TUNL TUNR GND VDSENS 10u VD2 NM C753 C751 CCG1192-A 7.4V C754 0.1u/10 D751 MECHA VD 47k 10k AGND VDD3.3V 0 L411 NM 8.2 R428 *2 8.2 1/4W DGND 1/4W R410 R412 USB&USB5V RF GND *2 *2 *2 2 3 9p/50 C431 ANTENNA 1M R402 1u/10 C408 C421 C427 C443 C444 C452 C455 L404 L405 L406 L409 L416 L417 L418 L420 R405 GNDLNA 17 D402 C417 LNAIN 18 LNADEC 10u 19 C418 CCG1192-A KP2311E L407 0.1u/10 C419 64 TVDAC 63 C416 TCFM 62 0.22u/16 PLLTEST 61 GND-PLL 60 R406 0.1u/10 0.1u/10 C451 VCC-PLL 20 LNAIN2 C420 LNAOUT2 21 LNAOUT 22 33 0.1u/10 R407 23 LNADEC2 C449 NM NM 56 AMMIXIN2 C427 C406 C444 L417 R431 C428 9p/50 24 L409 53 R409 NM CTF1786-A L408 59 VCC-ADC_DAC C426 55 CTF1786-A 58 DACOUTR 57 DACOUTL 54 0.1u/10 GNDSLINK 26 AMMIXIN1 52 C429 50 31 VDIG 27 R433 28 C434 C422 0.1u/10 C421 1k R427 B.UP ROT1 KEYD SWVDD5 ML CDWAIT CDSTBY CDSRQ CDRST CPPW CPRST CP_SCL CP_SDA CD_SCL NM R430 NM R754 KN601 NM R417 NM R416 GND C602 SI IC671 110 0.1u/10 130 129 128 127 126 125 124 123 122 121 120 119 118 117 116 115 114 113 112 111 109 0.1u/10 C671 R671 47k CE# SO WP# VSS 1 2 3 4 NC CP_SDA CP_SCL TUNSDA TUNSCL ROT1 KEYD SWVDD VSS11 PVCC10 NC DACCS CDWAIT CDSTBY CDSRQ CDRST VSS10 CPPWR PVCC9 CPRST CN701 GND NM C706 SO NM C703 NM C702 NM C704 100k R717 GND DGND NM NM C710 NM C709 NM C708 C707 PGND NM C705 GND L671 CTF1786-A PEB011A8 CD_SCL NM C IC671 PEB012A8 SCK 7 HOLD# 8 VDD 6 5 *5 C~F A,B NM R721 CD_SDA 0.1u/10 C601 R605 M2R6TP_GND R704 4.7k 2 7 1 3 6 8 4 5 *5 SI SCK GND 0.01u/16 100k C701 R703 100k 47k R702 R701 VD1 VD 1 CD CN701 VKN1192 FLASH ROM 820 R753 VDCONT VDD3.3V SW5V 6 5 2 1 4 RN4983 Q752 3 CD_SDA GND RKZ8.2KG(B2) D~F 15p 22p 2p 0.01u 8p L415 49 32 NM C436 VDCONT R419 R752 C447 51 30 C435 NM C437 C438 NM 25 R408 C423 0.01u/16 NM C NM 100p 82p 0.01u NM NM NM 0.27uH CTF1389 22uH 47uH CTF1786 NM NM NM DAC CD/USB:+5.22 dBs SYSTEM MICRO R5S7266ZD144FP IC601 NM C235 C234 CCG1192-A 10u D GND 2 2 X601 CSS1603-A 1 3 1 3 820 R231 820 R232 A-b 16.934MHz B.U VDD SW NM L231 NC AVCC DM DP VBUS USBDVCC USBDVSS REFRIN USBAPVSS USBAPVCC USBAVCC USBAVSS USBUVCC USBUVSS MODELAD NC VDSENS NC AVSS KEYAD AVREF 3 11 VSS I2C_SCL/SPI_SIMO 12 I2C_SDA/SPI_SOMI MODE0/SPI_CLK 13 VCC NC8 nRESET 14 NC2 MODE1/SPI_nSS NC1 15 1000p/50 GND-ADC_DAC VREFDEC GND-REF OSCOUT OSCIN VCC-REF VDDIO1V2 VDDPLL1V2 C452 R418 0.1u/10 CTF1786-A C439 C455 29 C433 NM 10k R420 R415 A,B NM 100p 82p NM NM 1u 10p 0.27uH CTF1389 22uH 47uH NM NM NM 68n NM R601 VCCREG1V2 REG1V2 VREG3V3 RSTN RDSINT C430 10k NM R414 D601 RB551V-30 VD 2 A-a A-b 100k 4 /CDSTBY 220 SCL 220 108 *2 10k R603 3 /CDSRQ CDSRQ 100 C605 106 CDSRQ R707 CDSTBY R708 CD_SCL R709 CDSTBY SDA SKIP SCL 5 SDA VDD RESET 8 RESET 6 107 TUNPCE1 NM R718 SKIP 220 CDSKIP R710 TUNPCE2 R634 7 100 R711 CD_SDA VCC6 CDWAIT 9 VDD4 L701 47k 104 DATA 150 R713 10 GND 11 DATA BCLK 150 R714 NM 12 BCLK 13 LRCK LRCK R715 NM CDDATAIN 1k R712 CDRST R672 0.1u/10 105 RSPCK MD 14 GND 15 PGND R719 C607 BCK 16 WAIT 220 R720 102 C238 C237 DGND1 NM 103 VSS9 /SSL MC LRCK R611 89 CDSCKIN CE 0.1u/10 MOSI 101 PVCC8 ML DATA R613 150 CDLRCKIN MISO 100 TUNPCK 99 RDS_INT SCK 88 PGND WAIT R716 98 TUNPDI NM 97 NC TUNPDO CDSCKIN 96 CDSCKIN C609 CDDATAIN 0.1u/10 94 VCC5 CDLRCKIN 95 CDLRCKIN 93 CADATAIN DATA SCK NM NM 100 IC231 CDSKIP R614 PVCC7 R609 91 NM C613 100 BCK MC C617 NM DACLRCK C612 90 LRCK 10p/50 C239 C620 220 C611 92 VSS8 0.1u/10 except C C619 1000p/50 0.1u/10 NM C615 100 16 1 SCK BCK 2 15 ML DATA 3 14 LRCK MC 13 4 MD DGND 12 5 NC ZEROL/NA 6 ZEROR/ZEROA 11 VCC VCOM 10 VOUTL AGND 9 VOUTR TCK R617 MD 8 C232 0.01u/16 TMS R616 DACDATA 0.1u/10 DACSCK 8 R619 7 NM PCM1753DBQ C233 7 2 1 TDO 3 TDI 2 R618 CCG1192-A 10u 1 6 42 5 A-a ASEBRK F DACBDATA 87 86 CDSKIP 85 DACBSCK 84 AUDIO_XOUT 83 VCC4 82 VSS7 81 PVCC6 80 AUDIO_X1 79 AUDIO_X2 78 TCK TMS 77 TDI 76 TDO ASEBRKAK/ASEBRK 75 TRST 74 E 3 D 4 C TRST B 47k A 2 73 1 4 0.1 C 7 6 MIC1P VCC 3 2 1 U1IN U1OUT GND 4 NRST_CPU 5 8 MIC1N 10 SPKR 9 11 VSS VSS 12 SPKL VSS R 6 5 4 3 2 1 1 3 2 GND 13 CN961 VKN1189 W.REM&MIC (W/R) (RMIC) JA891 YKS5035 W.REM JA892 CKS4124 4 GND 0 R965 1k 1k R966 NM L961 1u/10 R964 GND R963 8.2k C963 R962 8.2k 1u/10 C964 GND KEYAD GND 62k C503 GND L501 CTH1475-A ipod CP GND R891 R892 GND 1k 1k GND GND 1u/16 C509 3 2 1 KEYD2 RT GND VIN /OC VOUT 10k R969 C968 470p/50 4 5 BD9008F INV EN/SYNC FB SW BT MOD KEYAD2 IC501 PVIN BD2232G-G EN GND VIN IC510 4 3 2 1 A GND 4 3 2 1 5 6 7 8 USB&USB5V GND IN+1 IN-1 OUT1 GND 10k R972 IN+2 IN-2 OUT2 VCC IC961 NJM4558MD USBCTL FLG 5 6 7 8 NM 10k R968 C967 470p/50 SYS+B L962 NM SYNC LPF GND NM R507 51k R506 CRG03 CRG03 D503 D502 ASENS SSENS BSENS RGBDT A-a A-b CN1821 DP AUXGND AUXR SOURCE AUXL DSENS CKS6288 4 5 6 7 8 9 10 11 GRILLE DGND 1 ROT1 SWVDD 3 2 ILMGND ILM+B ROT0 RGBDT/USBGND KYDT USBGND DPDT USB5V RGBCK/ILMCLR1 DM 13 12 14 15 16 17 18 19 20 DSENS1 CN801 R691 RGBST/ILMCLR2 ILMCLR2 ILMCLR1 ILMPW ROT0 ROT1 KEYD SWVDD5 ML B BTR BTL BTRST BTRX BTTX KEYAD KEYD USBCTL FLG VBUS SYNC CPRST CDWAIT CDSTBY CDSRQ CDRST R818 NM R814 2.2k 0.1u/16 DSENS C818 GND RGBDT NM 0.1u/10 137 136 135 134 133 132 131 130 129 128 127 126 125 124 123 122 C802 CDRST CDSRQ NC SSENS ASENS BSENS DSENS BTTESTMD BTTESTIN RGBDT VSS12 ILMCLR2 PVCC11 ILMCLR1 ILMPW ROT0 ROT1 KEYD SWVDD VSS11 PVCC10 NC DACCS CDWAIT CDSTBY 0.1u/16 C803 ILMG D GND USBGND ILM GND 0.1u/16 USGND DGND SWVD ROT1 ILM ROT0 KYDT DPDT2 US5V ICLR1 DM ICLR2 DP AUXG AUXR SRC AUXL 144 143 142 141 BTTESTMD 140 138 NM BTTESTIN 139 R641 0.1u/10 C603 C602 R605 0 121 R817 R816 IC601 R5S7266ZD144FP 22k R801 22k R815 R802 100 100 100 2.2k R804 R810 2.2k R808 2.2k 2.2k 2.2k R811 R803 2.2k 44 R812 GND 3 3 L801 CTF1713-A 2 2 11 2.2k RES PLLVCC PLLVSS MD_CLK0 MD_BOOT0 EXTAL XTAL VSS5 PVCC5 VSS6 USB_X1 USB_X2 ASEMD USBDPVCC USBDPVSS DM DP VBUS USBDVCC USBDVSS REFRIN USBAPVSS DP AUXR AUXG AUXL SSENS 8 A-b GND D SWV NM L851 ROT1 ROT0 KYDT ILMCLR1 DM 8.2 ILMCLR2 R805 8.2 R806 R807 USBAVCC USBAVSS USBAPVCC 7 The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. NM : No Mount 220p/16 GND NM C505 NOTE : Symbol indicates a resistor. No differentiation is made between chip resistors and discrete resistors. Symbol indicates a capacitor. No differentiation is made between chip capacitors and discrete capacitors. GND GND MIC1N MIC1PF KEYD VR105C5R0AAA VA894 C970 NM USB5V C892 GND R556 2.7k R557 4.7k R501 C891 220u/6.3 C552 0.1u/10 0.1u/16 VA893 0.1u/16 18k 5 11 VSS I2C_SCL/SPI_SIMO 12 4 I2C_SDA/SPI_SOMI MODE0/SPI_CLK 13 3 VCC NC8 nRESET 2 NC2 14 MODE1/SPI_nSS 15 1 NC1 VA892 NM R503 R502 R504 3.6k 12k 470 C502 VA891 C508 NC9 NC10 18 NC11 NC12 19 NC13 20 C511 R505 C506 1u/10 D501 RB160L-40 NM C510 C965 22p/50 NM 0.015u/16 NM D961 NC7 8 NC6 NC5 7 NC4 NC3 6 R967 R961 IC551 341S2162 10k 47k 47k R971 17 C512 C966 16 220p/50 C507 C513 CCG1192-A 9 10k 10 C961 R601 4 5 100k 3 6 10k R603 2 7 47k 1 8 NM 220p/50 NM R973 R508 10k 1 C604 D601 RB551V-30 R604 47k NM 2 0.1u/10 CP_SDA D809 DZ2S068C CP_SCL DIM R561 1u/10 10u C962 C969 1u/16 10k R970 0.1u/10 ANTPW NM SYSPW PVCC2 13 100 C606 C809 0.1u/16 /RDSLK 100 2.2k NM 3 PVCC1 4 NC 5 VSS1 DIMMER 6 VCC1 PCL 7 ANTPW SYSPW 8 PCL D804 DZ2S068C 9 R607 D803 DZ2S068C VCC2 17 R560 D805 DZ2S068C SYNC R559 25 R602 R813 RGBDT D808 34 R553 10k NM C801 47k R620 R552 10k R608 TELIN 47k BTRST TELIN1 TELIN 10 BT RST ROM 11 ROM 12 RAM_MON RAM_MON 47k C608 VDCONT 14 VDCONT 18 0.1u/10 VSS2 15 D801 DZ2S068C 0.1u/10 C812 1u/16 D802 DZ2S068C USBCTL USBCTL 16 R612 47k 0.1u/16 C808 C610 D806 NM TESTIN /USBFLG 20 2.2k FLG 19 R610 D807 DZ2S068C 21 NM MUTE PVCC3 22 R615 100k VCC3 0.1u/10 C618 TESIN 23 C616 VDT 26 VST VST 27 VDT MUTE D811 DZ2S068C C614 SYNC D810 DZ2S068C 29 KYDT VSS3 24 0.1u/10 C810 220p/50 C811 220p/50 32 C621 VCK 30 VCK KYDT/TESTDI 31 BTTX BTTX 33 0.1u/10 PVCC4 CKIO VSS4 BTRX NMI 35 BTRX DPDT/TESTDO 28 DPDT 8.2k 7 R809 6 4.7k 36 R642 5 R851 DEH-34UB/XNUC C851 6 NM 5 8 A-a 43 A B C D E F 44 1 E DEH-3450UB/XNES1 F DEH-3490UB/XNID B 2 F 3 R1897 NM NM RGB DEH-34UB/XNUC 4 R1884 100 1 DGND IC1851 14 1 CSS1547-A X1801 LSC4081UB(QRS) NM R1896 Q1864 LSC4081UB(QRS) GREEN 180 Q1856 R1885 100 180 LSC4081UB(QRS) R1886 1 NM C1862 2 1k 1 SMLV56RGB1U1(Q) C1866 R1877 S1832 R1871 100 EJECT 4 G 2 3 1 S1836 Q1859 LSC4081UB(QRS) 3 S1831 120 2 S1825 2 R1872 2 220 1 R1873 5 S1839 5 R 4 S1835 6 B 6 S1830 2 KST1 1 1 R1858 100 KDT1 KDT3 KDT2 3 0.1u/16 D1853 S1829 C1854 LIST S1828 Q1854 LSC4081UB(QRS) 1 1 180 2 2 R1859 1 1 2 S1822 180 RED S1833 R1860 Q1851 1 R1881 100 LSC4081UB(QRS) RIGHT NM 2 1k 2 Q1863 LSC4081UB(QRS) KST3 180 2 R1882 2 1 2 180 1 2 R1883 24 2 1 NM C1861 ILMGND 1 1 SMLV56RGB1U1(Q) C1865 R1864 SOURCE 1 R1868 100 25 3 2 1 Q1858 LSC4081UB(QRS) 28 * 120 S1824 4G 2 R1869 18 1 220 SEG36 R1870 S1823 5 R 2 6B COLOR 2 KST0 KDT0 UC, ES, ES1, ID EW5 1 2 R1855 100 S1821 0.1u/16 D1852 C1853 Q1853 LSC4081UB(QRS) LEFT 180 R1856 SEG35 SEG34 SEG33 SEG32 SEG31 SEG30 SEG29 SEG28 SEG27 SEG26 SEG25 SEG24 SEG23 SEG22 SEG21 SEG20 2 180 17 R1857 1k DPDT R1878 100 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 GRILLE uCON NM REMOTE R1851 KYDT DPDT 20 REM 19 Q1862 LSC4081UB(QRS) 23 X0 MODA 22 KYDT NC1 21 180 KDT2 R1879 KDT3 26 180 27 R1880 KST4 NM C1860 NM 29 R1865 100 R1806 SEG39 G Q1857 LSC4081UB(QRS) SEG38 30 120 R1866 47k SEG37 31 220 R1867 CCG1192-A 10u/10 32 SMLV56RGB1U1(Q) C1864 4 C DEH-3400UB/XNEW5 3 SEG35 SEG34 SEG33 SEG32 SEG31 SEG30 SEG29 SEG28 SEG27 SEG26 SEG25 SEG24 SEG23 SEG22 SEG21 * CLOCK PTY R B DEH-3400UB/XNUC 3 D DEH-3450UB/XNES B A DEH-34UB/XNUC 5 E 6 IC1802 GP1UXC14RK 2 GRILLE uCON & LCD :1801-1820 KEY MATRIX& CONNECTOR :1821-1850 RGB :1851-1910 USB :1911-1920 AUX :1921-1930 VCC R1805 KDT3 1 SEGMENT LCD R1852 100 V1801 0.1u/16 D1851 C1852 CAW2018 NM X1 C1801 KDT1 VSS SEG11 SEG10 SEG9 SEG8 SEG7 SEG6 SEG5 2 16 SEG12 GND 15 KDT0 KST0 KDT0 KDT1 KST2_2 180 14 KST0 KST1 IC1801 R1804 13 KST1 KST2_1 SEG36 SEG37 SEG38 SEG39 KST4 NC2 1 12 KST3 VLCD COM0 COM1 COM2 COM3 SEG0 SEG19 SEG18 SEG17 SEG16 SEG15 SEG14 180 D PD6581A REM C KST2 64 11 63 VDD KST3 SEG5 SEG13 10 62 COM0 SEG6 9 61 COM1 60 SEG7 8 SEG8 7 59 COM2 SEG9 6 58 COM3 57 SEG10 5 SEG11 SEG0 SEG12 56 SEG1 55 4 54 SEG1 SEG13 3 53 SEG2 52 SEG14 SEG20 SEG15 SEG4 SEG3 SEG2 51 2 50 SEG16 1 1u/10 C1802 SEG17 SEG3 DGND SEG18 SEG4 NM L1801 B 49 Q1852 LSC4081UB(QRS) SEG0 SEG1 SEG2 SEG3 SEG4 SEG5 SEG6 SEG7 SEG8 SEG9 SEG10 SEG11 SEG12 SEG13 SEG14 SEG15 SEG16 SEG17 SEG18 SEG19 SEG20 SEG21 SEG22 SEG23 SEG24 SEG25 SEG26 SEG27 SEG28 SEG29 SEG30 SEG31 SEG32 SEG33 SEG34 SEG35 SEG36 SEG37 SEG38 SEG39 COM0 COM1 COM2 COM3 SEG19 R1853 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 A R1854 SEG0 SEG1 SEG2 SEG3 SEG4 SEG5 SEG6 SEG7 SEG8 SEG9 SEG10 SEG11 SEG12 SEG13 SEG14 SEG15 SEG16 SEG17 SEG18 SEG19 SEG20 SEG21 SEG22 SEG23 SEG24 SEG25 SEG26 SEG27 SEG28 SEG29 SEG30 SEG31 SEG32 SEG33 SEG34 SEG35 SEG36 SEG37 SEG38 SEG39 COM0 COM1 COM2 COM3 1 4 10.2 KEYBOARD UNIT KEY MATRIX SOURCE KYDT S1834 DPDT BAND S1837 2 1 S1838 2 ROTAR COMMAN KST2 5 S1842 4 DISP/BACK S1840 CSD1168- 1 2 S1841 1 KST4 SOURCE S1826 S1827 5MHz DGND CCG1205 C1851 only C 2.2u DGND 0.01u/ C185 R1803 DGND except C Q1861 BLUE LSC40 Q18 RED R GREEN BLUE 5 6 7 8 A B KEYBOARD UNIT URCE DT DT CN1821 CKS6287 ROTARY COMMANDER S1842 NM 27k R1821 R1822 ILMGND 5V 1 ILMGND 2 ROT1 14.2V 3 4 DGND SWVDD 3 2 5 DGND 5 ROT0 6 RGBDT 7 1 DGND R1801 KYDT CSD1168R1802 DPDT 2.2k 10p/50 10p/50 C1857 C1858 9 10 USB5V 11 RGBCK 12 R1911 NM R1912 NM A CN801 DM 13 RGBST 14 DP 15 AUXGND 16 AUXR 17 SOURCE 18 AUXL 19 DSENS 20 C DGND L1911 NM 2.2k R1895 10p/50 2.2k R1894 C1856 2.2k R1893 8 USBGND 2.2k B 4 ILM+B C1851 CCG1205-A USB 2.2u DGND CN1911 BU2507FV VCC VDD 2 3 4 NM D1911 C1911 0.1u/16 6 0.01u/50 DGND NM 5 C1859 D1912 10 11 8 1 7 Ao5 6 Ao4 5 12 9 Ao6 LD CLK 4 13 3 Ao3 RESET DI Ao1 Ao2 2 1 VSS IC1851 GND 14 CKS6267 USBGND C1912 D NM NM NM C1922 C1921 NM D1922 180 B 3 2 1 C1867 4 0.1u/16 R 5 R1887 100 Q1865 LSC4081UB(QRS) G 6 E ILMGND 180 180 R1889 R1888 R1874 100 Q1860 LSC4081UB(QRS) 180 180 150 R1876 R1875 0.1u/16 0.1u/16 C1863 Q1855 LSC4081UB(QRS) R1862 R1861 100 C1855 NM R1863 R1884 100 Q1864 LSC4081UB(QRS) 180 180 NM C1862 3 SMLV56RGB1U1(Q) C1866 5 R 4 G 2 220 R1886 120 R1885 R1871 100 AUX:+2.2 dBs NM BLUE LCD GREEN LCD RED LCD 3 2 1 LSC4081UB(QRS) C1923 LSC4081UB(QRS) LSC4081UB(QRS) LUE Q1868 D1921 B(QRS) Q1867 R1922 R1921 JA1921 CKN1090 Q1866 NM NM ILMGND AUX DGND 1k R1892 1k R1891 1k R1890 1k R1877 0.1u/16 NSSM038A-6430 D1854 F B DEH-34UB/XNUC 5 6 7 8 45 1 2 3 4 10.3 CD CORE UNIT (S11.6STD) PICKUP UNIT(P10.6) (SERVICE) A CXX3556 V3R3 2.4 4.7u/6.3 (2125) C104 2.4 2.7 (1/10W) (1/10SR,1608) R101 R102 R103 LD1 Q102 LTA123JUB VCC TOP TRK ACT 4 4 3 3 2 2 1 1 D101 NM TOM C220 FOM 0.1u/10 C RFI TOP 82 R229 83 470 84 C217 R216 85 56p/50 1.2k 86 EQ1 RF2RFA.GND2 88 A.VDD2 89 A BD 90 F 91 E 92 B F E 93 REFO d C229 0.1u/10 c TE C225 TEC C223 94 68p/50 95 FEO 96 ADCIN C236 REFOUT FE- FE 0.1u/10 R101 R102 R103 R246 ADCIN C224 97 47p/50 98 TETEO 99 0.01u/16 100 C239 C104 CXE2273 TE2 TEC 2125:PARTS M1 SPDL MOTOR EQ2 C222 0.1u/10 NM AC RFO 87 C204 CKS4808-A 27p/50 E F BD AC TOP FOP FOM TOM 81 RFO C228 NM CN101 1608:PARTS C205 C209 C238 C240 C307 C308 C708 Land for manual soldering C3T C219 0.1u/10 AGCI FOP REFO2 * AGCO 80 REFO1 NO MOUNT PARTS (NM) A.GND1 79 1800p/50 RFAGC C205 F.ACT: Applying positive voltage to FOP, the lens approaches DISC. T.ACT: Applying positive voltage to TOP, the lens moves outer circumference of DISC. 74 75 ATEST f PD LD FOP 5 78 2 FOM 6 5 A.VDD1 77 C216 1 TOM 6 PD NM MD AC 0.1u/10 5.6k A+C 76 C221 4.7k 7 4p/50 7 F REFO C218 8 VR R218 R217 9 8 VREF NM 9 P1+P6 E C201 10 NM 11 10 EFM ATEST NM 11 V+3A BD V+3A 1M 12 R108 13 12 C101 GND 14 13 39 ASY NM P5+P10 14 R2 C110 VCC 15 C111 B+D 15 NM C102 LD+ FOCUS ACT LD 2SA1577(QR) 2.2k LD- HOLOGRAM UNIT R109 C214 Q101 LD B R R R R PUEN 0.047u/16 E:P5+P10 F:P1+P6 LD PD BLK SOM Parts with Polarity IC201 IC301 D101 Q101 Q102 Q201 RED SOP VDD C202 D C301 GND BL LCOM YW C312 5 LCOP NM CSN1080-A 8SNS S905 NM FOP 7 FOM 8 TOM 9 2 8SNS 1 DSCSNS 2 S903 6 DSCSNS 10 TOP CSN1081-A DSCSNS SWITCHES: CD CORE UNIT (S11.6STD) S901:HOME SWITCH.........ON-OFF S903:DSCSNS SWITCH.....ON-OFF C308 11 1u/10 (1608) 12 13 CLCONT LOEJ 4 CONT MOTOR DRIVER LOGIC TABLE CLCONT LOEJ CONT EJ PLAY OFF H H L H L L L L H L VD CLCONT LOEJ CONT DEH-34UB/XNUC 1 LOAD PGND C 46 5 TD The underlined indicates the switch position. F VDD 1 FD C301 C306 14 SD a9 NM LCOM 4 NM 3 C313 2 SOP MD NM SOM NM 8 SIN SPIN 28 POWVCC CIN SLIN 27 SPOC315 BIAS 26 SPO+ FIN NM 25 TKIN SLLDOTIN FCIN 24 SLLDO+ CNT 23 POWGND LDIN 22 TKO- 29 GND 21 MUTE TKO+ PRTOUT 20 FCOPREGND 19 FCO+ 47k PRTLIM 18 R309 TKRNF PRTF 17 FCRNF 16 PRTT TKCDET PREVCC 15 FCCDET C314 HOME 2 431 431 43 1 HOME 1 0.1u/10 HOME 3 S901 7 IC301 BD8223EFV C307 1u/10 (1608) E CN702 ACTUATOR/ MOTOR DRIVER CXC4026 2 3 2 LCOP M2 LOAD/CRG MOTOR 4 PUEN 12k 12k R303 R304 SKIP /CDSRQ 10k Mask 51 LRCK0 /CDSRQ /TESTIN 52 SKIP 53 55 54 /PUEN /ADENA VDCONT 56 57 VDSENS 58 TEMP 59 MONITOR_0 MONITOR_1 60 62 61 MONITOR_2 63 SD2 MONITOR_3 50 PC3 A.GND1 SDA RFI SCL 78 AGCO 8 0 7 0 81 82 R229 83 470 84 R216 85 TX/EMPH SCKO RF AMP, CD DECODER DIGITAL SERVO/DATA PROCESSOR CPU DOUT PA7 LOEJ RF2- 1.2k 86 CLCONT RF87 A.GND2 IC201 A.VDD2 PE5791A 88 CONT DSCSNS 89 NC A 90 EJSW E 93 /CDSTBY REFOUT C223 94 ICECK FE95 68p/50 FEO IO.VDD1 ADCIN IO.GND1 96 C224 97 47p/50 TE- RESET TEO C.GND 98 99 C.VDD TE2 NM NM C235 SCL C283 NM R283 44 R281 0 56 43 R282 56 LRCK 56 R292 BCLK C281 C282 0 NM NM R293 DATA 42 C284 0 41 NM R202 0 LOEJ 40 R201 0 CLCONT 39 R264 1k CONT 38 DSCSNS 37 8SNS 35 HOME EJSW 34 33 R245 R253 100k NM C 100k R240 47k /CDSTBY ICECK 32 ICECK R297 31 C211 30 NM 0.1u/10 29 R237 C233 28 27 C210 26 0.1u/10 RESET 220 0.01u/16 R232 XTAL VPP X.GND VPP CVDD CVDD VDD2 C299 0.1u/10 VDD VD2 RESET VD1 SCL SDA SKIP CDSRQ CN701 CKS6146-A I/O VPP 9 SCK 7 ICECK 5 6 VD /CDSRQ VDD 1 CDSTBY GND NM CVDD 3 D VDD1 3 (1608) NM C240 2 ICEMD 0.1u/10 0.1u/16 (1608) 0.1u/16 (1608) CVDD ICECK VPP X201 CSS1603-A 16.934 MHz C209 10 GND SCK C238 SCK NM 8 SI 6 SO 4 CN702 2 RESET C202 C203 A0 STB RST INTQ 1 25 /XTAL 24 470 ICEMD X.VDD 23 R294 22 DA.VDD SDA R291 0 21 20 LOUT 19 REGC DA.GND1 ROUT DA.VDD1 DA.GND 18 17 16 15 14 REG16 REGS 13 D.GND 12 D.VDD SI 9 SI 11 10 SO SO 8 SCK /SCK A0 6 7 /STB VPP INTQ(INT1) /RST 4 3 PD LD 2 1 NM C239 TEC 5 100 /WAIT R254 HOME F 92 0 36 12SNS B 91 22 ADENA BSCK0 45 LRCK RFO EQ1 56 470 B ADENA 46 AGCI EQ2 22 47 /WAIT C3T C219 56 48 80 0.1u/10 Flash 10k 22 49 79 1800p/50 0 56 0 C216 IO.GND2 IO.VDD2 A.VDD1 77 64 65 66 67 TD FD SD 68 70 71 69 MD TEST AD.GND 72 73 EFM AD.VDD 75 74 ASY ATEST 76 R232 R281 R282 R291 R294 GND TESTIN TEMP TH201 NM Q201 NM ATEST TEMP R296 R260 C16M MONI0 MONI2 b MONI1 MDX 0.1u/10 (1608) R246 VDD e MDY 10k C215 R214 39k EFM ADENA TEMP C212 C213 0.1u/10 GND R215 ASY A CD CORE UNIT (S11.6STD) 4.7k R306 4.7k 4.7k 4.7k 4.7k 3300p/50 C214 R308 4.7k 0.1u/10 8 PUEN C305 0.022u/16 R310 R311 R312 R313 7 C 1000p/50 1000p/50 C304 0.047u/16 0 R307 1k R305 SD 1k R302 TD C302 C303 0 R301 FD 6 MD 5 /CDSTBY R709 0 R706 SCL R702 220 SKIP 100 R701 R708 SDA 0 100 RESET 1 VD 7.5V 2 VD 7.5V 3 /CDSRQ 4 /CDSTBY 5 SCL 6 SKIP 7 SDA 8 RESET 9 VDD 10 GND DATA NM (1608) C708 NM C707 NM C705 C710 1000p/50 GND 15 PGND GND 16 WAIT IIC-BUS Digital GND3 GND2 GND1 LRCK WAIT DATA BCLK NM NM C701 NM NM C702 PGND C703 L NM L H R710 L R711 H L L 14 GND i h g F PGND2 OFF 13 LRCK /WAIT PGND1 PLAY CN701 GND 12 BCLK LRCK J 3.3V E 11 DATA BCLK LOGIC TABLE A C DEH-34UB/XNUC 5 6 7 8 47 1 2 3 4 10.4 WAVEFORMS - CD CORE UNIT(S11.6STD) A 1DSCSNS 3HOME 4LOEJ 5 V/div 5 V/div 5 V/div Note : 1. The encircled numbers denote measuring points in the circuit diagram. 2. Reference voltage REFO1(1.65 V) 500 ms/div 1DSCSNS 5CLCONT 4LOEJ 6VD1 5 V/div 5 V/div 5 V/div 10 V/div 12 cm CD Loading operation 12 cm CD Loading operation Ref.: GND Ref.: GND Mode: Normal Mode: Normal 500 ms/div B 7SIN 8CIN 9TIN aFIN 200 mV/div 500 ms/div bRFOK(MONI_2) 2 V/div 7SIN 2 V/div cTE dFE 12 cm CD-DA setup operation after loading 12 cm CD-DA Source On setup operation Source On setup operation Ref.: REFO Ref.: REFO Ref.: REFO Mode: Normal Mode: Normal Mode: Normal 1 V/div 500 mV/div 500 mV/div 1 s/div 500 mV/div 200 ms/div 500 mV/div C dFE aFIN cTE 9TIN D E 500 mV/div 500 mV/div 500 mV/div 500 mV/div 48 eMDX 7SIN 2 V/div 50 ms/div 500 mV/div eMDX 7SIN 5 μs/div 2 V/div 500 mV/div CD-DA Play operation Spindle waveform during play operation Spindle waveform during play operation (Wider) Ref.: REFO Ref.: REFO Ref.: REFO Mode: Normal Mode: Normal Mode: Normal aFIN dFE F 20 ms/div 500 mV/div 200 ms/div 500 mV/div cTE fRFAGC 500 mV/div 500 mV/div 2 ms/div fRFAGC cTE 9TIN 1 V/div 500 μs/div 500 mV/div 500 mV/div Focus Search waveform Track Open waveform 100 Track Jump waveform (32 Track Jump x 3) Ref.: REFO Ref.: REFO Ref.: REFO Mode: TEST Mode: TEST Mode: TEST DEH-34UB/XNUC 1 2 3 4 5 fRFAGC cTE 9TIN 6 1 V/div 500 mV/div 500 mV/div 2 ms/div fRFAGC cTE 8CIN 7SIN 7 1 V/div 200 ms/div 1 V/div 500 mV/div 2 V/div 8 gLRCK 2 V/div hBCLK 2 V/div iDOUT(DATA) 2 V/div 32 Tracks Jump waveform (Zoom of 100 Track Jump waveform) Search operation(Outter to Inner) Digital Out waveform Ref.: REFO Ref.: REFO Ref.: GND Mode: TEST Mode: Normal Mode: Normal 1DSCSNS 5CLCONT 4LOEJ 5 V/div 5 V/div 5 V/div 1DSCSNS 3HOME 4LOEJ 500 ms/div B 5 V/div 5 V/div 5 V/div 12 cm CD Eject operation 12 cm CD Eject operation Ref.: GND Ref.: GND Mode: Normal Mode: Normal fRFAGC 9TIN cTE aFIN 1 V/div 1 V/div 1 V/div 1 V/div A 10 us/div 500 ms/div C 500 μs/div Black Dot (800 μm) during play D Ref.: REFO Mode: Normal E F DEH-34UB/XNUC 5 6 7 8 49 1 2 3 4 11. PCB CONNECTION DIAGRAM 11.1 TUNER AMP UNIT > P 251 (A,7,128) Fuse 3 A W. REM JA892 C313 C254 1 C253 D503 C510 C505 C503 R501 C502 R502 R504 R503 R506 C507 C334 R334 R332 D502 C261 120 15 C316 C251 1 IC301 5 VA893 C252 R252 1 R891 10 1 C308 Q251 R892 C306 VA891 6 C302 4 C307 SIDE B Q252 R258 C258 R254 R251 C255 R255 P251 R259 R253 C257 R257 C260 Chip Part JA891 C259 VA894 130 P.C.Board 2 1 C304 SIDE A 3 C892 3 2 5 C305 5 C891 1 C301 6 JA251 C303 PRE OUTPUT 4 B CEK1286 150 140 Capacitor Connector TUNER AMP UNIT C331 R331 R333 C333 A C314 C317 1.The parts mounted on this PCB include all necessary parts for several destination. For further information for respective destinations, be sure to check with the schematic diagram. 2.Viewpoint of PCB diagrams VA892 NOTE FOR PCB DIAGRAMS R256 C256 A 5 C508 IC501 R507 C506 R505 D501 C514 1 110 C509 L501 1 100 C 90 80 70 D 60 50 40 C E CN701 30 20 10 F B Y 50 FRON 0 A X 10 20 30 40 50 60 DEH-34UB/XNUC 1 2 CN1821 3 4 70 80 5 6 7 8 A SIDE A CEK1286 POWER SUPPLY 1 5 9 13 16 D301 C312 C351 C319 1 17 Q752 R753 D954 C318 B C901 ANTENNA R301 D902 Q301 C210 C206 R952 R951 D951 C513 C512 IC510 1 D875 C458 C417 C416 60 55 50 C615 L413 L414 D872 D871 C872 D911 R871 D873 C238 C613 E Q873 D D912 R881 R419 R429 L416 C437 R421 R410 R415 C612 C871 R885 C235 10 15 C636 L231 C233 R639 C634 C239 R231 R232 IC231 1 5 C622 R621 C630 R873 Q872 1 C922 C231 C928 L601 C924 C925 C929 L602 R640 C912 C911 C920 C916 C918 C914 C917 R911 C926 C921 R721 R912 C923 C919 C915 IC912 5 E 1 D874 R882 R883 C511 C234 C429 L419 C873 E E C232 R628 D602 C428 1 X401 C237 C620 10 R716 R880 R874 Q871 X601 1 R619 1 C635 C637 C638 R632 R420 R614 R616 R618 C632 R703 C701 C611 R617 C619 C426 C435 C431 C432 L412 Q874 R611 C617 R718 R719 R720 C705 C706 C438 C439 R562 C624 L415 R613 L408 C425 C424 45 C442 C441 R417 R634 C609 R609 70 R631 C623 R876 R875 C704 R412 C552 R557 R558 R605 C601 65 R630 R637 R623 C628 60 C626 R626 C625 R620 C621 C651 D651 R651 R627 R962 R968 5 1 R601 R603 R641 C967 R970 C964 C963 10 15 10 75 5 80 C627 R633 R717 1 85 55 X602 1 C633 40 C440 C436 C607 90 50 R752 R751 R707 R701 R708 R709 R710 R711 R712 R702 35 C447 C L407 R409 R877 C605 95 CN701 C707 C708 100 45 R625 R636 R622 R624 R704 1 R713 R714 R715 35 L701 40 R629 C631 C629 IC401 R427 R430 R418 R416 110 30 C702 1 IC651 115 25 C618 R964 R642 120 IC601 20 R508 C616 R201 R966 1 C652 125 15 C610 R610 130 105 R608 C608 C614 R615 135 10 L961 C965 C703 L671 C602 R414 140 R433 C454 C434 L411 R428 C433 R612 C604 R607 D961 D601 C603 1 C606 C422 L410 R602 R604 C671 R402 C419 R408 C452 C427 C457 C455 5 5 C970 1 R671 1 R965 20 R559 R552 R553 R560 R561 R972 C961 L962 C710 C709 C962 C969 CN961 5 5 C966 1 R963 15 L401 C406 C409 D402 C448 30 IC961 R672 C449 C410 25 R967 R556 IC671 R691 1 R969 C421 L409 C413 C446 R434 C420 R407 R401 C403 C402 20 R961 C968 10 R971 C423 E IC551 R973 R406 Q551 C430 R551 C551 C418 KN601 R413 C415 C445 R405 C412 L404 C414 R403 L406 L551 C443 L403 L405 R431 C450 C404 L402 C214 C456 L418 C444 C213 R432 P401 C401 D401 L420 C411 C405 C407 C951 C408 R934 D952 Q931 C451 L417 5 C952 E C931 R933 C209 C217 C207 C211 C205 R205 R941 1 R932 Q941 L201 IC951 D931 E C202 10 C913 C204 1 1 R931 R206 KN401 C927 Q951 Q953 Q952 R942 10 R943 5 C215 C203 IC201 1 1 L941 15 C201 20 E E D941 R207 JA401 D901 R879 1 18 R878 R352 R304 R302 R303 R351 R353 Q351 1 C212 C216 C208 C311 14 C315 C308 C307 C306 C302 C334 R334 R332 C332 C304 C305 C301 10 15 C303 6 C309 D751 C754 R754 1 10 C331 R331 R333 C333 2 15 C310 Q751 E C320 D302 25 15 5 5 L901 JA901 C753 C751 C321 FUSE 20 IC301 1 10 R884 D876 R872 C851 CN1821 80 D804 D803 D806 D802 D805 C812 R817 R816 1 D807 D801 D810 R804 D808 L801 R811 R814 1 C809 5 C818 15 10 20 F CN801 FRONT 70 R813 C810 D811 C817 R851 D809 C811 C803 C801 R818 R802 R815 C808 R807 R801 R806 IC801 15 R812 R805 R809 R803 L851 R808 C802 R810 C852 90 100 110 120 130 140 DEH-34UB/XNUC 5 6 A 160 150 7 8 51 1 A A 2 3 4 TUNER AMP UNIT 1 B 1 C PCL D TESTIN 1 E 1 1 F A 52 160 150 140 130 120 110 100 90 DEH-34UB/XNUC 1 2 3 4 80 5 6 7 8 A SIDE B 150 1 140 1 1 130 B 120 110 100 C 90 80 70 D 60 50 40 E 30 20 10 F Y 0 80 70 60 50 40 30 20 10 DEH-34UB/XNUC 5 6 0 X 7 A 8 53 B 54 1 2 0 3 20 30 40 50 BAND 60 S1838 RIGHT S1834 70 S1836 1 D 10 5 2 80 S1825 90 3 S1831 V1801 20 100 S1835 4 5 15 5 120 S1839 10 130 S1830 6 5 1 140 * S1824 USB AUX 3 JA1921 150 1 CN1911 2 160 A 110 1 D1852 SEGMENT LCD 25 5 X S1837 1 D1854 30 2 Y S1841 S1842 D1851 S1833 35 6 DSIP/BACK 5 5 40 4 10 1 D1853 1 S1827 1 S1840 S1822 LEFT S1821 S1826 SOURCE 3 COLOR S1823 E ROTARY COMMANDER C 2 20 30 LIST S1828 IC1802 1 S1829 UC, ES, ES1, ID EW5 B S1832 * CLOCK PTY B 40 F EJECT 1 3 4 11.2 KEYBOARD UNIT KEYBOARD UNIT SIDE A 5 1 DEH-34UB/XNUC 4 D1911 R1804 L1911 1 R1911 R1912 C1912 R1806 R1803 R1802 R1801 5 2 L1801 C1802 1 55 R1921 R1922 C1922 15 CN1821 10 50 D1912 D1921 19 20 C 100 1 5 60 90 IC1801 10 15 R1894 R1895 80 X1801 1 R1805 Q1868 Q1867 IC1851 R1893 R1822 Q1865 E R1889 E R1863 R1851 E Q1866 E Q1860 Q1855 R1888 R1877 60 R1876 R1862 C1860 C1864 C1852 50 Q1861 Q1851 Q1856 40 Q1852 30 C1854 C1866 R1853 R1852 Q1854 Q1862 R1859 Q1864 R1885 R1878 E R1869 R1854 R1867 R1880 R1879 R1860 R1886 R1873 R1857 R1883 R1882 10 R1870 R1881 R1871 R1884 Q1859 R1872 20 Q1858 R1868 R1855 R1856 Q1853 Q1863 C1862 R1865 Q1857 R1866 R1896 E R1858 R1897 E F X 0 10 20 30 40 B Y 8 55 DEH-34UB/XNUC D R1892 R1821 C1851 70 R1875 CN801 A 110 E E E C1801 D1922 C1923 C1921 C1865 C1861 C1853 120 E E E E E B 130 E R1890 R1861 R1864 45 1 140 R1887 R1891 R1874 C1856 C1859 E E C1855 C1863 5 30 25 20 40 1 150 C1858 35 A 160 C1857 C1867 10 1 C1911 7 6 5 SIDE B KEYBOARD UNIT B 8 7 6 5 E 1 2 3 4 11.3 CD CORE UNIT (S11.6STD) C CD CORE UNIT (S11.6STD) SIDE A A PICKUP UNIT(P10.6)(SERVICE) 60 B CN101 15 10 5 1 R246 R232 M2 LOADING/CARRIAGE MOTOR R254 TH201 C235 1 HOME C102 S901 C201 50 D101 CN702 R253 R245 1 5 10 F E C238 C R706 C240 C205 C710 R297 C299 40 C707 R701 C220 C705 R702 M1 SPINDLE MOTOR 30 D CN701 15 10 5 A 1 CN701 C702 20 C307 R710 C701 C308 C312 E R306 R303 R304 R201 R308 REFO1 10 5 1 IC301 10 R307 R305 R301 R302 R264 R202 15 20 25 C306 R309 Y 0 F X 10 20 30 40 50 C 56 DEH-34UB/XNUC 1 2 3 4 5 7 8 CD CORE UNIT (S11.6STD) SIDE B A 60 R101 R103 R102 C104 B Q102 R108 Q101 E C202 E X201 1 50 R109 R294 C203 C239 C209 15 20 25 R240 90 85 R291 C218 R218 R216 R229 C219 45 C283 R292 C204 C222 IC201 40 C281 C282 C301 40 R293 R282 R283 R281 35 C284 95 E C C223 80 Q201 30 C211 C101 C111 C236 C229 R296 C110 C224 100 10 C210 5 C233 R237 C225 1 C 6 C217 C228 R217 C216 C221 50 55 60 65 70 75 30 R215 R214 C215 C212 R709 R708 R260 D S905 C708 1 C214 C213 20 E R711 C703 1 C305 C304 C302 C303 C313 C314 C315 R313 R312 R311 R310 DSCSNS 10 S903 Y 0 50 40 30 20 10 F X C DEH-34UB/XNUC 5 6 7 8 57 1 2 3 4 12. ELECTRICAL PARTS LIST A B NOTE: Parts whose parts numbers are omitted are subject to being not supplied. The part numbers shown below indicate chip components. Chip Resistor RS1/_S___J,RS1/__S___J Chip Capacitor (except for CQS.....) CKS....., CCS....., CSZS..... The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. Meaning of the figures and others in the parentheses in the parts list. Example) IC 301 is on the point (face A, 91 of x-axis, and 111 of y-axis) of the corresponding PC board. IC 301 (A, 91, 111) IC NJM2068V Circuit Symbol and No. C D E Circuit Symbol and No. Part No. A:DEH-34UB/XNUC B:DEH-3400UB/XNUC C:DEH-3400UB/XNEW5 D:DEH-3450UB/XNES E:DEH-3450UB/XNES1 F:DEH-3490UB/XNID Unit Number : QWM3310(A,B) : QWM3309(C) : QWM3311(D,E,F) Unit Name : Tuner Amp Unit Unit Number : (A,B,D,E,F) : (C) Unit Name : Keyboard Unit Unit Number : CWX4023 Unit Name : CD Core Unit (S11.6STD) A Unit Number : QWM3310(A,B) Unit Name : QWM3309(C) : QWM3311(D,E,F) : Tuner Amp Unit MISCELLANEOUS F IC 201 IC 231 IC 301 IC 401 IC 501 (A,98,112) (A,144,57) (A,78,141) (A,150,90) (A,20,113) IC 510 IC 551 IC 601 (A,107,30) IC (A,115,90) IC (A,118,65) IC 58 IC D/A Converter IC IC IC PML022A PCM1753DBQ PAL007E TDA7706 BD9008F BD2232G-G 341S2162 R5S7266ZD144FP Part No. IC 651 IC 671 (A,98,53) IC S-80827CNMC-B8M (A,126,85) Flash ROM Unit(A,B) PEB012A8 (A,126,85) Flash ROM Unit(C,D,E,F) PEB011A8 IC 801 IC 912 Q 251 Q 252 Q 351 (A,108,19) (A,145,28) (A,23,130) (A,13,129) (A,88,127) Q Q Q Q Q 551 751 752 873 874 (A,122,93) Transistor LSA1576UB (A,142,138) Transistor 2SD2396 (A,140,133) Chip Transistor RN4983 (A,161,73) Transistor LTC143EUB (A,151,70) Transistor 2SA1577 Q Q D D D D 931 941 301 302 401 402 (A,118,104) Transistor (A,113,108) Transistor(C) (A,100,126) Diode (A,96,126) Diode (A,158,106) Diode (A,158,99) Diode LSC4081UB LSA1576UB CRG03 CRG03 KP2311E KP2311E D D D D D 501 502 503 601 602 (A,29,109) (A,20,124) (A,20,122) (A,117,81) (A,127,50) RB160L-40 CRG03 CRG03 RB551V-30 RB751S-40 D D D D D 751 801 802 803 804 (A,138,134) Diode (A,114,13) Diode (A,117,12) Diode (A,121,12) Diode (A,126,12) Diode RKZ8.2KG(B2) DZ2S068C DZ2S068C DZ2S068C DZ2S068C D D D D D 805 807 809 810 811 (A,122,12) Diode (A,113,13) Diode (A,96,14) Diode (A,108,14) Diode (A,102,14) Diode DZ2S068C DZ2S068C DZ2S068C DZ2S068C DZ2S068C D D D D 873 874 875 876 (A,151,65) (A,122,30) (A,118,29) (A,122,26) CRG03 CRG03 CRG03 CRG03 D 901 D 902 D 911 L-MOS And Gate TC7SET08FUS1 IC BA49182-V12 Chip Transistor RN1910 Chip Transistor(A,B,D,E,F) RN1910 Chip Transistor RN4983 Diode Diode Diode Diode Diode Diode Diode Diode Diode (A,139,125) Diode (A,136,125) Diode (A,158,65) Diode 1SR154-400 1SR154-400 1SR154-400 DEH-34UB/XNUC 1 2 3 4 5 6 Circuit Symbol and No. D 912 D 931 D 941 L L L L 401 402 403 404 L 405 L 406 L 407 L 408 L 409 7 Part No. Circuit Symbol and No. (A,162,65) Diode 1SR154-400 (A,116,107) Diode(A,B,D,E,F) HZU7L(A1) (A,116,107) Diode(C) HZU7L(C3) (A,113,114) Diode(C) 1SS301 (A,159,102) (A,151,101) (A,146,102) (A,155,103) (A,155,103) (A,142,103) Chip Coil LCTAWR15J2520 Inductor CTF1786 Inductor CTF1786 Chip Coil(A,B,C) LCTAWR27J2520 Chip Coil(D,E,F) LCTAWR39J2520 Inductor(A,B,C) CTF1389 (A,139,101) Inductor(A,B,C) LCTAW220J2520 (A,139,101) Chip Coil(D,E,F) LCTAW1R5J2520 (A,162,95) Inductor CTF1786 (A,162,94) Inductor CTF1786 (A,137,93) Chip Coil(A,B,C) LCTAW470J2520 (A,137,93) Inductor(D,E,F) LCTAW2R2J2520 L L L L 415 416 417 418 (A,146,81) Inductor CTF1786 (A,154,79) Inductor(C) CTF1786 (A,138,107) Chip Coil(D,E,F) LCTAWR39J2520 (A,142,105) Chip Coil(D,E,F) LCTAWR27J2520 L L L L L L 420 501 671 801 901 941 (A,145,106) Inductor(A,B) LCYB68NJ1608 (A,34,109) Coil CTH1475 (A,131,81) Inductor CTF1786 (A,116,15) Inductor CTF1713 (A,112,140) Choke Coil 600 uH CTH1432 (A,110,111) Inductor(C) LCTAW2R2J2520 X 401 X 601 X 602 > P251 P 401 CN701 CN801 JA251 JA401 JA892 JA901 > (A,113,140) Plug Fuse(10 A) CKM1586 YEK5001 RESISTORS R R R R R 201 231 232 251 252 (A,100,59) (A,147,56) (A,148,56) (A,19,130) (A,29,131) RAB4CQ102J RS1/16SS821J RS1/16SS821J RS1/16SS821J RS1/16SS821J R R R R R 253 254 255 256 257 (A,9,129) (A,B,D,E,F) (A,18,130) (A,B,D,E,F) (A,21,130) (A,26,130) (A,11,129) (A,B,D,E,F) RS1/16SS821J RS1/16SS821J RS1/16SS223J RS1/16SS223J RS1/16SS223J R R R R R 258 303 304 331 332 (A,15,130) (A,B,D,E,F) (A,86,122) (A,86,125) (A,74,125) (A,81,125) RS1/16SS223J RS1/16SS103J RS1/16SS473J RS1/16SS471J RS1/16SS471J R R R R 333 334 351 352 (A,75,125) (A,80,125) (A,91,127) (A,90,127) RS1/16SS471J RS1/16SS471J RS1/16SS103J RS1/16SS103J R 353 (A,91,128) RS1/16SS221J R 401 R 402 R 403 (A,161,106) (A,161,99) (A,139,103) (A,B,C) (A,139,103) (D,E,F) (A,142,99) (A,137,96) (A,B,C) (A,137,96) (D,E,F) RS1/16SS221J RS1/16SS751J RS1/16SS152J RS1/16SS331J RS1/16SS105J RS1/16SS471J RS1/16SS361J R 410 R 412 R 413 (A,139,95) (A,138,91) (A,B,C) (A,138,91) (D,E,F) (A,136,79) (A,137,84) (A,145,107) RS1/16SS330J RS1/16SS681J RS1/16SS391J RS1/4SA8R2J RS1/4SA8R2J RS1/16SS105J R R R R R 419 420 421 427 428 (A,139,70) (A,141,70) (A,153,79) (A,B,D,E,F) (A,142,84) (A,139,86) RS1/16SS103J RS1/16SS103J RS1/16SS0R0J RS1/16SS102J RS1/16SS0R0J R R R R R R 431 433 434 501 502 503 (A,137,104) (A,B) (A,141,90) (A,B,C) (A,144,97) (D,E,F) (A,22,119) (A,24,117) (A,22,117) RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J RS1/10SR471J RS1/16SS6202D RS1/16SS3601D R R R R R 504 505 506 508 551 (A,20,119) (A,27,113) (A,15,114) (A,104,64) (A,115,95) RS1/16SS1202D RS1/16SS183J RS1/16SS513J RS1/16SS103J RS1/16SS473J R R R R R 552 553 556 557 558 (A,116,85) (A,117,85) (A,119,91) (A,120,90) (A,122,90) RS1/16SS103J RS1/16SS103J RS1/16SS272J RS1/16SS472J RS1/16SS472J R R R R R 559 560 601 602 603 (A,115,85) (A,118,85) (A,116,83) (A,114,80) (A,115,83) RS1/16SS101J RS1/16SS101J RS1/16SS103J RS1/16SS473J RS1/16SS104J R R R R R 604 607 608 609 610 (A,104,76) (A,104,70) (A,104,69) (A,132,66) (A,103,65) RAB4CQ473J RS1/16SS473J RS1/16SS473J RS1/16SS101J RS1/16SS222J R R R R R 611 612 613 615 617 (A,139,64) (A,106,76) (A,142,64) (A,103,63) (A,132,62) RS1/16SS101J RS1/16SS473J RS1/16SS101J RS1/16SS104J RS1/16SS221J R R R R R 619 620 621 622 623 (A,135,55) (A,105,57) (A,131,52) (A,106,50) (A,113,51) RAB4CQ473J RS1/16SS473J RS1/16SS473J RS1/16SS473J RS1/16SS152J R R R R R R 624 626 628 629 630 631 (A,108,50) (A,121,51) (A,127,51) (A,106,54) (A,125,50) (D,E,F) (A,125,52) (A,B,C) RS1/16SS473J RS1/16SS5601F RS1/16SS103J RS1/16SS102J RS1/16SS473J RS1/16SS473J R 405 R 406 R 407 R 408 DEH-34UB/XNUC 5 6 A B C (A,161,87) Oscillator 36.48 MHz CSS1805 (A,134,59) Ceramic Resonator 16.934 MHz CSS1603 (A,114,49) Oscillator 12 MHz YSS5005 (A,7,128) Fuse 3 A CEK1286 (A,155,108) Surge Protector IMSA-6802-01Y900 (A,92,38) Connector VKN1192 (A,109,3) Connector CKS6288 (A,19,137) Pin Jack(A,B,D,E,F) CKB1099 (A,19,137) Pin Jack(C) CKB1056 (A,158,128) Antenna Jack YKS5041 (A,42,138) Connector CKS4124 8 Part No. 7 8 D E F 59 1 Circuit Symbol and No. 2 3 Part No. R 943 A B C R R R R R 632 633 636 642 651 (A,121,43) (A,117,43) (A,109,51) (A,92,53) (A,101,53) RS1/16SS103J RS1/16SS101J RS1/16SS473J RS1/16SS473J RS1/16SS104J R R R R R 671 672 701 702 703 (A,131,86) (A,126,91) (A,97,43) (A,97,37) (A,99,41) RS1/10SR473J RS1/10SR473J RS1/16SS473J RS1/16SS104J RS1/16SS104J R R R R R 704 707 708 709 710 (A,97,47) (A,97,44) (A,97,42) (A,97,41) (A,97,40) RAB4CQ472J RS1/16SS221J RS1/16SS221J RS1/16SS101J RS1/16SS221J R R R R R 711 712 713 714 715 (A,97,39) (A,97,38) (A,97,35) (A,97,34) (A,97,33) RS1/16SS101J RS1/16SS102J RS1/16SS151J RS1/16SS151J RS1/16SS151J R R R R R 716 717 751 752 753 (A,96,31) (A,97,32) (A,97,45) (A,99,45) (A,143,133) RS1/16SS221J RS1/16SS104J RS1/16SS473J RS1/16SS103J RS1/10SR821J R R R R R 801 802 803 804 805 (A,121,18) (A,124,18) (A,102,18) (A,109,14) (A,117,18) RS1/10SR101J RS1/10SR101J RS1/10SR222J RS1/10SR222J RS1/10SR8R2J R R R R R 806 807 808 809 810 (A,118,18) (A,125,18) (A,100,18) (A,104,18) (A,99,19) RS1/10SR8R2J RS1/10SR222J RS1/10SR222J RS1/16SS822J RS1/10SR222J R R R R R 811 812 813 815 816 (A,114,16) (A,120,18) (A,105,14) (A,123,18) (A,124,16) RS1/10SR222J RS1/10SR222J RS1/10SR222J RS1/10SR101J RS1/16SS223J R R R R R 817 818 851 871 872 (A,121,16) (A,127,18) (A,96,16) (A,154,67) (A,125,26) RS1/16SS223J RS1/10SR222J RS1/16SS472J RS1/10SR473J RS1/16SS1R0J R R R R R R 874 875 877 885 891 892 (A,154,71) (A,125,39) (A,151,74) (A,157,72) (A,54,133) (A,58,136) RS1/16SS122J RS1/16SS0R0J RS1/16SS103J RS1/16SS152J RS1/10SR102J RS1/10SR102J R R R R R 911 912 931 932 933 (A,140,40) (A,144,41) (A,121,105) (A,118,106) (A,115,106) (A,B,D,E,F) (A,115,106) (C) RS1/10SR1R0J RS1/10SR1R0J RS1/16SS223J RS1/16SS473J RS1/16SS472J RS1/16SS473J (A,115,113) (A,112,105) (C) (A,112,111) (C) RS1/4SA102J RS1/16SS102J RS1/16SS223J D E F R 934 R 941 R 942 60 4 Circuit Symbol and No. (A,111,111) (C) Part No. RS1/16SS153J CAPACITORS C C C C C 201 202 203 204 205 (A,106,108) 10 uF (A,100,105) (A,103,108) 4.7 uF (A,100,106) (A,93,105) CCG1192 CCSSCH100D50 CCG1201 CCSSCH100D50 CKSRYB105K10 C C C C C 206 207 208 209 210 (A,93,118) (A,97,106) (A,97,118) (A,99,106) (A,99,118) CKSRYB105K10 CKSRYB105K10 CKSRYB105K10 CKSRYB105K10 CKSRYB105K10 C C C C C C 211 212 213 215 232 233 (A,94,104) (A,95,118) (A,123,103) (C) (A,102,107) (A,144,52) (A,149,54) 10 uF CKSRYB105K10 CKSRYB105K10 CCSSCH101J50 CCSSCH100D50 CKSSYB103K16 CCG1192 C C C C C 234 237 238 239 251 (A,145,63) 10 uF (A,148,60) (A,149,64) (A,147,58) (A,31,129) 4.7 uF CCG1192 CCSRCH182J50 CCSRCH182J50 CKSSYB102K50 CCG1201 C C C C C 252 253 254 255 256 (A,35,130) 4.7 uF CCG1201 (A,31,126) 4.7 uF(A,B,D,E,F) CCG1201 (A,35,127) 4.7 uF(A,B,D,E,F) CCG1201 (A,20,130) CCSSCH101J50 (A,28,130) CCSSCH101J50 C C C C C 257 258 259 301 302 (A,10,129) (A,B,D,E,F) (A,17,130) (A,B,D,E,F) (A,33,135) (A,74,128) (A,81,128) CCSSCH101J50 CCSSCH101J50 CKSSYB102K50 CKSRYB474K10 CKSRYB474K10 C C C C C 303 304 305 306 307 (A,76,128) (A,79,128) (A,74,131) (A,81,131) (A,76,131) CKSRYB474K10 CKSRYB474K10 CKSRYB474K10 CKSRYB474K10 CKSRYB474K10 C C C C C 308 309 310 311 312 (A,79,131) (A,135,134) (A,83,128) 2.2 uF (A,82,131) 2.2 uF (A,98,127) CKSRYB474K10 CKSRYB104K16 CCG1205 CCG1205 CKSRYB104K16 C C C C C 313 314 315 317 318 (A,67,128) (A,61,135) (A,84,130) (A,62,136) (A,107,129) CEVW100M16 CCSSCH101J50 CCSSCH101J50 CCSSCK1R0C50 CCSRCH100D50 C C C C C 319 320 321 351 401 (A,103,129) (A,96,133) (A,92,136) (A,93,127) 10 uF (A,155,106) CCSRCH100D50 CCSRCH100D50 CCSRCH100D50 CCG1192 CCSSCH330J50 C C C C C 402 403 404 405 406 (A,158,104) (A,161,104) (A,150,100) (A,147,99) (A,160,101) CCSSCH6R0D50 CKSSYB103K16 CKSSYB104K10 CKSSYB104K10 CKSSYB103K16 DEH-34UB/XNUC 1 2 3 4 5 Circuit Symbol and No. 6 C C C C C C 407 408 409 410 411 412 (A,148,100) (A,141,107) (D,E,F) (A,162,101) (A,148,98) (A,145,100) (A,144,100) 10 uF CKSSYB104K10 CCSSCH150J50 CKSSYB103K16 CKSSYB103K16 CKSSYB103K16 CCG1192 C C C C C 413 414 415 416 417 (A,155,101) (A,152,102) (A,141,99) (A,159,96) (A,160,95) CKSSYB103K16 CKSRYB105K10 CKSSYB103K16 CKSRYB224K16 CKSSYB104K10 C C C C 418 419 420 421 (A,139,98) 10 uF (A,158,93) (A,139,96) (A,137,95) (A,B,C) (A,137,95) (D,E,F) (A,140,92) CCG1192 CKSRYB105K10 CKSSYB104K10 CCSSCH101J50 CCSSCH220J50 CKSSYB104K10 C 422 7 Part No. (A,105,62) (A,133,63) (A,B,D,E,F) CKSSYB104K10 CCSSCH100D50 C C C C C 618 619 620 621 622 (A,104,60) (A,132,61) (A,138,58) (A,106,57) (A,130,52) CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 C C C C C 623 624 625 626 627 (A,124,51) (A,123,50) (A,122,51) (A,120,51) (A,118,51) CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 C C C C C 628 629 630 632 633 (A,114,51) (A,108,52) (A,128,52) (A,115,47) (A,113,47) CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CCSSCH120J50 CCSSCH120J50 C C C C C 638 651 671 701 751 (A,122,43) (A,105,53) (A,131,83) (A,100,41) (A,147,131) 10 uF CKSRYB105K10 CKSRYB105K10 CKSSYB104K10 CKSSYB103K16 CCG1192 C C C C C 754 802 803 808 809 (A,141,135) (A,93,20) (A,90,14) (A,113,18) (A,125,9) CKSSYB104K10 CKSRYB104K16 CKSRYB104K16 CKSRYB104K16 CKSRYB104K16 C C C C C 810 811 812 817 818 (A,100,15) (A,98,13) (A,123,12) (A,108,17) (A,124,6) CCSRCH221J50 CCSRCH221J50 CKSRYB105K16 CKSSYB104K10 CKSRYB104K16 C C C C C 872 891 892 901 913 (A,154,69) (A,34,139) (A,50,138) (A,133,124) 3 300 uF/16 V (A,141,40) CKSRYB104K16 CKSRYB104K16 CKSRYB104K16 CCH1732 CKSSYB102K50 914 916 917 918 919 (A,141,42) (A,150,41) (A,138,40) (A,153,42) (A,144,39) CCG1201 CCG1201 CCG1201 CCG1201 CKSSYB102K50 423 424 425 426 427 (A,136,95) (A,162,91) (A,162,92) (A,158,90) (A,138,90) (A,B,C) (A,138,90) (D,E,F) CKSSYB103K16 CKSSYB472K25 CKSSYB472K25 CKSSYB104K10 CCSSCH820J50 CCSSCK2R0C50 C C C C 428 429 430 431 (A,161,89) (A,161,84) (A,139,85) (A,B,C) (A,158,84) (A,B,C) CCSSCH9R0D50 CCSSCH9R0D50 CKSRYB474K10 CKSSYB104K10 C C C C 432 433 437 439 (A,157,82) 2.2 uF(D,E,F) (A,140,83) (D,E,F) (A,156,81) (A,145,79) (D,E,F) CCG1205 CKSSYB104K10 CKSSYB104K10 CKSRYB104K16 C C C C C C C 440 441 443 444 445 447 452 (A,147,82) (A,152,81) 2.2 uF (A,145,104) (C,D,E,F) (A,139,104) (D,E,F) (A,142,101) (A,142,85) (A,134,90) (A,B) CKSSYB104K10 CCG1205 CKSSYB103K16 CCSSCH8R0D50 CKSSYB223K16 CKSSYB102K50 CKSSYB105K6R3 C C C C C 455 457 458 503 505 (A,137,88) (A,B) (A,139,89) (A,B) (A,148,107) (A,B) (A,32,119) (A,11,119) Capacitor CCSSCH100D50 CKSSYB105K6R3 CCSSCJ3R0C50 CEVQW221M6R3 CEVW221M16 C C C C C C C C C C 506 508 509 510 512 (A,27,114) (A,26,114) (A,24,109) (A,40,121) (A,113,29) CKSSYB153K16 CCSSCH220J50 CKSRYB105K16 CKSRYB105K10 CKSRYB105K10 C 920 C 921 C 922 C C C C C 551 552 601 602 603 (A,116,95) (A,119,90) (A,121,78) (A,118,78) (A,114,78) CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 C C C C C 604 605 606 607 608 (A,106,73) (A,131,72) (A,104,72) (A,132,71) (A,106,67) CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 C 609 C 610 C 612 (A,132,67) (A,105,66) (A,136,66) CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 4.7 uF 4.7 uF 4.7 uF 4.7 uF C 923 C 926 (A,147,42) 4.7 uF CCG1201 (A,133,39) CKSRYB104K16 (A,157,54) (A,B,C) CEAT102M16 (A,157,54) 1 000 uF/16 V(D,E,F)CCH2024 (A,154,40) CKSSYB102K50 (A,133,41) CKSRYB102K50 C 931 (A,114,105) A B C D E CKSRYB104K16 B Unit Number : (A,B,D,E,F) Unit Name : (C) : Keyboard Unit MISCELLANEOUS IC 1801 IC 1802 DEH-34UB/XNUC 6 Part No. C 616 C 617 C C C C C 5 8 Circuit Symbol and No. F (B,85,23) IC PD6581A (A,159,36) Remote IC(A,B,D,E,F) GP1UXC14RK 7 8 61 1 2 Circuit Symbol and No. A B C 3 Part No. IC 1851 Q 1851 Q 1852 (B,66,16) DAC (B,48,22) Transistor (B,28,30) Transistor BU2507FV LSC4081UB LSC4081UB Q Q Q Q Q 1853 1854 1855 1856 1857 (B,23,11) (B,18,24) (B,56,25) (B,48,19) (B,22,31) Transistor Transistor Transistor Transistor Transistor LSC4081UB LSC4081UB LSC4081UB LSC4081UB LSC4081UB Q Q Q Q Q 1858 1859 1860 1861 1862 (B,19,8) Transistor (B,18,17) Transistor (B,59,25) Transistor (B,48,26) Transistor (B,15,26) Transistor LSC4081UB LSC4081UB LSC4081UB LSC4081UB LSC4081UB Q Q Q Q Q 1863 1864 1865 1866 1867 (B,19,11) (B,18,21) (B,61,28) (B,55,16) (B,64,20) Transistor Transistor Transistor Transistor Transistor LSC4081UB LSC4081UB LSC4081UB LSC4081UB LSC4081UB Q D D D D 1868 1851 1852 1853 1854 (B,64,23) (A,50,20) (A,112,6) (A,21,20) (A,64,21) Transistor LED LED LED Chip LED LSC4081UB SMLV56RGB1U1(Q) SMLV56RGB1U1(Q) SMLV56RGB1U1(Q) NSSM038A-6430 X 1801 S 1842 CN1821 CN1911 JA1921 (B,73,22) Ceramic Resonator 5.00 MHz CSS1547 (A,36,20) Encoder(ROTARY COMMANDER) CSD1168 (B,108,9) Connector CKS6287 (A,154,22) Connector CKS6267 (A,153,7) Jack CKN1090 V 1801 (A,138,32) Segment LCD CAW2018 RESISTORS D E F 4 Circuit Symbol and No. Part No. R R R R 1873 1874 1875 1876 (B,10,19) (B,61,21) (B,54,25) (B,54,28) RS1/10SR221J RS1/10SR101J RS1/10SR181J RS1/10SR181J R R R R R 1877 1878 1879 1880 1881 (B,58,15) (B,15,24) (B,10,27) (B,10,24) (B,12,10) RS1/10SR102J RS1/10SR101J RS1/10SR181J RS1/10SR181J RS1/10SR101J R R R R R 1882 1883 1884 1885 1886 (B,10,11) (B,10,13) (B,15,19) (B,15,21) (B,10,21) RS1/10SR181J RS1/10SR181J RS1/10SR101J RS1/10SR181J RS1/10SR181J R R R R R 1887 1888 1889 1890 1891 (B,62,25) (B,58,27) (B,56,28) (B,59,18) (B,61,18) RS1/10SR101J RS1/10SR181J RS1/10SR181J RS1/10SR102J RS1/10SR102J R R R R 1892 1893 1894 1895 (B,68,20) (B,65,10) (B,80,6) (B,80,8) RS1/10SR102J RS1/10SR222J RS1/10SR222J RS1/10SR222J CAPACITORS C C C C C 1801 1802 1851 1852 1853 (B,146,31) 10 uF(A,B,D,E,F) CCG1192 (B,97,23) CKSRYB105K10 (B,70,18) 2.2 uF CCG1205 (B,53,13) CKSRYB104K16 (B,131,6) CKSRYB104K16 C C C C C 1854 1855 1856 1857 1858 (B,22,21) (B,68,23) (B,62,11) (B,89,8) (B,88,8) CKSRYB104K16 CKSRYB104K16 CCSRCH100D50 CCSRCH100D50 CCSRCH100D50 C C C C C 1859 1863 1867 1911 1912 (B,61,11) (B,67,23) (B,70,23) (B,144,19) (B,133,28) CKSRYB103K50 CKSRYB104K16 CKSRYB104K16 CKSRYB104K16 CKSRYB104K16 R R R R R R 1801 1802 1803 1805 1822 1851 (B,110,22) (B,117,21) (B,131,24) (A,B,D,E,F) (B,74,17) (C) (B,65,8) (B,58,13) RS1/10SR222J RS1/10SR222J RS1/10SR101J RS1/10SR473J RS1/10SR273J RS1/10SR102J R R R R R 1852 1853 1854 1855 1856 (B,21,27) (B,21,29) (B,10,28) (B,23,14) (B,19,13) RS1/10SR101J RS1/10SR181J RS1/10SR181J RS1/10SR101J RS1/10SR181J R R R R R 1857 1858 1859 1860 1861 (B,10,18) (B,23,23) (B,15,22) (B,10,23) (B,59,21) RS1/10SR181J RS1/10SR101J RS1/10SR181J RS1/10SR181J RS1/10SR101J R R R R R 1862 1863 1864 1865 1866 (B,52,25) (B,52,28) (B,59,11) (B,19,31) (B,19,32) RS1/10SR181J RS1/10SR151J RS1/10SR102J RS1/10SR101J RS1/10SR121J IC 201 IC 301 Q 101 Q 102 X 201 (B,23,37) IC PE5791A (A,37,11) IC BD8223EFV (B,11,53) Transistor 2SA1577 (B,15,54) Chip Digital Transistor LTA123JUB (B,25,49) Ceramic Resonator 16.934 MHz CSS1603 R R R R R 1867 1868 1869 1870 1871 (B,10,30) (B,19,15) (B,15,8) (B,12,8) (B,15,16) RS1/10SR221J RS1/10SR101J RS1/10SR121J RS1/10SR221J RS1/10SR101J S 901 S 903 CN101 CN701 (A,42,53) (B,21,12) (A,16,58) (A,25,29) R 1872 (B,15,18) RS1/10SR121J 62 C Unit Number : CWX4023 Unit Name : CD Core Unit (S11.6STD) MISCELLANEOUS Spring Switch(HOME) CSN1080 Spring Switch(DSCSNS) CSN1081 Connector CKS4808 Connector CKS6146 RESISTORS DEH-34UB/XNUC 1 2 3 4 5 Circuit Symbol and No. 6 7 Part No. R R R R R 101 102 103 108 109 (B,6,57) (B,8,57) (B,9,57) (B,18,55) (B,12,50) RS1/10SR2R4J RS1/10SR2R4J RS1/10SR2R7J RS1/16SS105J RS1/16SS222J R R R R R 201 202 214 215 216 (A,24,11) (A,23,9) (B,18,28) (B,17,28) (B,12,35) RS1/16SS0R0J RS1/16SS0R0J RS1/16SS103J RS1/16SS393J RS1/16SS122J R R R R R 217 218 229 232 237 (B,10,32) (B,10,35) (B,12,34) (A,31,54) (B,33,45) RS1/16SS562J RS1/16SS472J RS1/16SS471J RS1/16SS0R0J RS1/16SS221J R R R R R 240 245 254 260 264 (B,34,40) (A,34,46) (A,37,56) (B,30,27) (A,22,9) RS1/16SS473J RS1/16SS104J RS1/16SS104J RS1/16SS103J RS1/16SS102J R R R R R 281 282 283 291 292 (B,33,38) (B,33,39) (B,35,38) (B,33,34) (B,33,36) RS1/16SS560J RS1/16SS560J RS1/16SS0R0J RS1/16SS560J RS1/16SS0R0J R R R R R 293 294 296 301 302 (B,35,39) (B,27,48) (B,34,43) (A,27,9) (A,28,9) RS1/16SS0R0J RS1/16SS471J RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J R R R R R 303 304 305 306 307 (A,27,11) (A,28,11) (A,26,9) (A,26,11) (A,25,9) RS1/16SS123J RS1/16SS123J RS1/16SS102J RS1/16SS472J RS1/16SS102J R R R R R 308 309 310 311 312 (A,25,11) (A,35,6) (B,30,9) (B,30,10) (B,30,11) RS1/16SS472J RS1/16SS473J RS1/16SS472J RS1/16SS472J RS1/16SS472J R R R R R 313 701 702 706 708 (B,30,12) (A,21,38) (A,23,38) (A,32,42) (B,28,26) RS1/16SS472J RS1/16SS101J RS1/16SS101J RS1/16SS221J RS1/16SS0R0J R 709 (B,29,28) RS1/16SS0R0J Circuit Symbol and No. 8 Part No. C C C C 218 219 220 221 (B,10,36) (B,14,34) (A,18,38) (B,14,32) CCSSCH4R0C50 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 C C C C C 222 223 224 225 228 (B,13,37) (B,12,42) (B,13,45) (B,13,46) (B,10,33) CKSSYB104K10 CCSSCH680J50 CCSSCH470J50 CKSSYB103K16 CCSSCH270J50 C C C C C 229 233 236 238 299 (B,9,40) (B,32,46) (B,8,40) (A,25,44) (A,26,41) CKSSYB104K10 CKSSYB103K16 CKSSYB104K10 CKSRYB104K16 CKSSYB104K10 C C C C C 302 303 304 305 306 (B,28,12) (B,29,12) (B,27,12) (B,26,12) (A,31,7) CKSSYB102K50 CKSSYB102K50 CKSSYB223K16 CKSSYB104K10 CKSSYB104K10 C 307 C 308 C 710 (A,41,19) (A,31,15) (A,34,42) CKSRYB105K10 CKSRYB105K10 CKSSYB102K50 A B Miscellaneous Parts List M 1 M 2 C Pickup Unit(P10.6)(Service) CXX3556 Motor Unit(SPINDLE) CXE2273 Motor Unit(LOADING/CARRIAGE) CXC4026 D E CAPACITORS C C C C C 104 203 209 210 211 (B,12,57) (B,22,47) (B,28,47) (B,33,43) (B,33,41) CKSQYB475K6R3 CKSSYB104K10 CKSRYB104K16 CKSSYB104K10 CKSSYB104K10 C C C C C 212 213 214 215 216 (B,22,28) (B,18,26) (B,17,26) (B,19,28) (B,12,33) CKSSYB104K10 CKSSYB332K50 CKSSYB473K16 CKSSYB104K10 CKSSYB182K50 C 217 (B,10,34) CCSSCH560J50 F DEH-34UB/XNUC 5 6 7 8 63