Download "service manual"

PROVISIONAL
CRT4804P
DVH-840AVBT/XEUW5
DVD AV RECEIVER
DVH-840AVBT
DVH-8480AVBT
/XEUW5
/XFBR
PIONEER CORPORATION 1-1, Shin-ogura, Saiwai-ku, Kawasaki-shi, Kanagawa 212-0031, Japan
PIONEER ELECTRONICS (USA) INC. P.O. Box 1760, Long Beach, CA 90801-1760, U.S.A.
PIONEER EUROPE NV Haven 1087, Keetberglaan 1, 9120 Melsele, Belgium
PIONEER ELECTRONICS ASIACENTRE PTE. LTD. 253 Alexandra Road, #04-01, Singapore 159936
PIONEER CORPORATION 2012
K-ZZZ JAN. 2012 Printed in Japan
1
2
3
4
SAFETY INFORMATION
This service manual is intended for qualified service technicians; it is not meant for the casual do-it-yourselfer.
Qualified technicians have the necessary test equipment and tools, and have been trained to properly and safety repair
complex products such as those covered by this manual.
Improperly performed repairs can adversely affect the safety and reliability of the product and may void the warranty.
If you are not qualified to perform the repair of this product properly and safety, you should not risk trying to do so
and refer the repair to a qualified service technician.
A
Where in a manufacturer’s service documentation, for example in circuit diagrams or lists
of components, a symbol is used to indicate that a specific component shall be replaced only
by the component specified in that documentation for safety reasons, the following symbol shall
be used:
B
- Safety Precautions for those who Service this Unit.
When checking or adjusting the emitting power of the laser diode exercise caution in order to get safe, reliable
results.
Caution:
1. During repair or tests, minimum distance of 13 cm from the focus lens must be kept.
2. During repair or tests, do not view laser beam for 10 seconds or longer.
CAUTION: USE OF CONTROLS OR
ADJUSTMENTS OR PERFORMANCE OF
PROCEDURES OTHER THAN THOSE
SPECIFIED HEREIN MAY RESULT IN
HAZARDOUS RADIATION EXPOSURE.
CAUTION: THE USE OF OPTICAL
INSTRUMENTS WITH THIS PRODUCT
WILL INCREASE EYE HAZARD.
C
This product is a class 1 laser product, but
this product contains a laser diode higher
than Class 1. To ensure continued safety,
do not remove any covers or attempt to
gain access to the inside of the product.
D
CAUTION
Danger of explosion if battery is incorrectly replaced.
Replaced only with the same or equivalent type recommended by the manufacturer.
Discord used batteries according to the manufacturer's instructions.
E
F
2
DVH-840AVBT/XEUW5
1
2
3
4
5
6
7
8
CONTENTS
SAFETY INFORMATION .....................................................................................................................................2
1. SERVICE PRECAUTIONS................................................................................................................................4
1.1 SERVICE PRECAUTIONS .........................................................................................................................4
1.2 NOTES ON SOLDERING...........................................................................................................................4
2. SPECIFICATIONS.............................................................................................................................................5
2.1 SPECIFICATIONS ......................................................................................................................................5
2.2 DISC/CONTENT FORMAT.........................................................................................................................8
3. BASIC ITEMS FOR SERVICE ..........................................................................................................................9
3.1 CHECK POINTS AFTER SERVICING .......................................................................................................9
3.2 PCB LOCATIONS.....................................................................................................................................10
3.3 JIGS LIST .................................................................................................................................................10
3.4 CLEANING ...............................................................................................................................................10
3.5 FACTORY SETTINGS.............................................................................................................................. 11
4. BLOCK DIAGRAM ..........................................................................................................................................12
4.1 BLOCK DIAGRAM....................................................................................................................................12
4.2 POWER BLOCK DIAGRAM .....................................................................................................................13
5. DIAGNOSIS ....................................................................................................................................................14
5.1 OPERATIONAL FLOWCHART.................................................................................................................14
5.2 ERROR CODE LIST.................................................................................................................................15
5.3 CONNECTOR FUNCTION DESCRIPTION .............................................................................................16
6. SERVICE MODE.............................................................................................................................................17
6.1 SOFTWARE VERSION INFORMATION DISPLAY ..................................................................................17
6.2 SOFTWARE VERSION UP METHOD......................................................................................................18
7. DISASSEMBLY ...............................................................................................................................................23
8. EACH SETTING AND ADJUSTMENT............................................................................................................27
9. EXPLODED VIEWS AND PARTS LIST ..........................................................................................................28
9.1 PACKING..................................................................................................................................................28
9.2 EXTERIOR (1) ..........................................................................................................................................30
9.3 EXTERIOR (2) ..........................................................................................................................................32
10. SCHEMATIC DIAGRAM................................................................................................................................34
10.1 MB UNIT (1/2) (GUIDE PAGE) ...............................................................................................................34
10.2 MB UNIT (2/2) (GUIDE PAGE) ...............................................................................................................40
10.3 SB SMT UNIT (POWER PART) (GUIDE PAGE) ....................................................................................46
10.4 SB SMT UNIT (MAIN PART) (GUIDE PAGE).........................................................................................52
10.5 KB PCB and AUX PCB (GUIDE PAGE) .................................................................................................58
10.6 CB PCB and LB PCB..............................................................................................................................64
11. PCB CONNECTION DIAGRAM ....................................................................................................................66
11.1 MB UNIT .................................................................................................................................................66
11.2 SB SMT UNIT .........................................................................................................................................70
11.3 KB PCB...................................................................................................................................................72
11.4 AUX PCB ................................................................................................................................................74
11.5 CB PCB...................................................................................................................................................75
11.6 LB PCB ...................................................................................................................................................76
12. ELECTRICAL PARTS LIST...........................................................................................................................77
A
B
C
D
E
F
DVH-840AVBT/XEUW5
5
6
7
8
3
1
2
3
4
1. SERVICE PRECAUTIONS
1.1 SERVICE PRECAUTIONS
A
1. You should conform to the regulations govering the product (safety, radio and noise, and other regulations),
and should keep the safety during servicing by following the safety instructions described in this manual.
2. Be careful about an internal sharp edge.
3. Be careful in handling ICs. Some ICs such as MOS type are so fragile that they can be damaged by
electrostatic induction.
4. Be careful in handing made from metal parts. There might be burr at the edge of it.
5. Two kinds of resetting are available
1 Turn over the Detach Panel and press RESET Button at Central Part.
Without entire initialization.
Microcomputer restarting (emergency resetting at function trouble) .
With the reset of the pioneer.
2 Perform [Default Setting] initialization in Setting
Perform product initialization except a part of items.
Please carry it out when updating software.
6. Any component parts in the CD Mechanism Unit of this model can not be supplied.
If you need to replace any parts in the CD Mechanism Unit, replace whole of CD Mechanism Unit.
B
C
1.2 NOTES ON SOLDERING
For environmental protection, lead-free solder is used on the printed circuit boards mounted in this unit.
Be sure to use lead-free solder and a soldering iron that can meet specifications for use with lead-free solders for repairs
accompanied by reworking of soldering.
Compared with conventional eutectic solders, lead-free solders have higher melting points, by approximately 40 C.
Therefore, for lead-free soldering, the tip temperature of a soldering iron must be set to around 373 C in general, although
the temperature depends on the heat capacity of the PC board on which reworking is required and the weight of the tip of
the soldering iron.
D
Compared with eutectic solders, lead-free solders have higher bond strengths but slower wetting times and higher melting
temperatures (hard to melt/easy to harden).
The following lead-free solders are available as service parts:
Parts numbers of lead-free solder:
GYP1006 1.0 in dia.
GYP1007 0.6 in dia.
GYP1008 0.3 in dia.
E
F
4
DVH-840AVBT/XEUW5
1
2
3
4
5
6
7
8
2. SPECIFICATIONS
2.1 SPECIFICATIONS
• DVH-840AVBT/XEUW5
General
A
Rated power source: ............................... 14.4 V DC (allowable voltage range: 10.8 V to 15.1
V DC)
Preout maximum output level: ................. 4.0 V
Maximum current consumption: ............. 10.0 A
Backup current: ....................................... 5 mA or less
Dimensions (W × H × D):
Chassis............................................ 178 mm × 50 mm × 165 mm
Nose ................................................ 188 mm × 58 mm × 22 mm
Weight: .................................................... 1.3 kg
Display
B
Screen size/aspect ratio: ......................... 3.5 inch wide/16:9 (effective display area: 76.32 mm
× 42.82 mm)
Pixels: ...................................................... 320 × (RGB) × 234
Display method: ..................................... TFT active matrix
Durable temperature range (power off) ... –20 °C to + 60 °C
DVD Player
System..................................................... DVD video, Video CD, CD,WMA, MP3, DivX, JPEG
system
Usable discs ............................................ DVD video, Video CD, CD, CD-R/RW, DVD±R/RW/
R DL
Region number ........................................ 5 for Russia
Frequency response ................................ 20 Hz to 20 kHz (with DVD, at sampling frequency
96 kHz)
Signal-to-noise ratio................................. 75 dB (1 kHz) (IEC-A network) (RCA level)
Output level:
Video ............................................... 1.0 Vp-p/75 (±0.2 V)
Number of channels ................................ 2 (stereo)
MP3 decoding format .............................. MPEG-1 & 2 Audio Layer 3
WMA decoding format ............................. Ver. 7, 7.1, 8, 9, 10, 11 (2ch audio) (Windows Media
Player)
DivX decoding format .............................. Home Theater Ver. 3, 4, 5.2, 6 (.avi, .divx)
DVD video output .................................... NTSC
C
Audio
Maximum power output: .......................... 50 W × 4
Continuous power output ... .................... 22W × 4 (50 Hz to 15 000 Hz, 5%THD, 4
both channels driven)
Load impedance: ..................................... 4 (4 to 8 (2 for 1 ch) allowable)
Preout maximum output level .................. 4.0 V
D
load,
Equalizer (8-Band Graphic Equalizer):
Frequency ......................................... 40/80/200/400/1k/2.5k/8k/10 kHz
Gain ................................................... ±12 dB
E
F
DVH-840AVBT/XEUW5
5
6
7
8
5
1
2
3
4
3
4
A
Gain................................................. ±12 dB
HPF:
Frequency....................................... 50 Hz/63 Hz/80 Hz/100 Hz/125 Hz
Slope............................................... –12 dB/oct
Subwoofer (mono):
Frequency....................................... 50 Hz/63 Hz/80 Hz/100 Hz/125 Hz
Slope............................................... –18 dB/oct
Gain................................................. +6 dB to –24 dB
Phase.............................................. Normal/Reverse
Bass boost:
Gain................................................. +12 dB to 0 dB
USB
B
USB standard specification: .................... USB 1.1, USB 2.0 full speed
Maximum current supply ......................... 1000mA
File system: ............................................. FAT16, FAT32
FM tuner
Frequency range: .................................... 87.5 MHz to 108.0 MHz)
Usable sensitivity ..................................... 10 dBµ (S/N: 30 dB)
AM tuner
Frequency range: .................................... 531 kHz to 1 602 kHz (9 kHz)
........................................................ 530 kHz to 1 640 kHz (10 kHz)
Usable sensitivity: .................................... 30 dBµ (S/N: 20 dB)
C
Bluetooth
Version .................................................... Bluetooth 2.0 certified
Output power ........................................... +4dBm Maximum(Power class 2)
D
E
F
6
DVH-840AVBT/XEUW5
1
2
5
6
7
8
• DVH-8480AVBT/XFBR
General
A
Rated power source: ............................... 14.4 V DC (allowable voltage range: 10.8 V to 15.1
V DC)
Preout maximum output level: ................. 4.0 V
Maximum current consumption: ............. 10.0 A
Backup current: ....................................... 5 mA or less
Dimensions (W × H × D):
Chassis............................................ 178 mm × 50 mm × 165 mm
Nose ................................................ 188 mm × 58 mm × 22 mm
Weight: .................................................... 1.3 kg
Display
B
Screen size/aspect ratio: ......................... 3.5 inch wide/16:9 (effective display area: 76.32 mm
× 42.82 mm)
Pixels: ...................................................... 320 × (RGB) × 234
Display method: ..................................... TFT active matrix
Durable temperature range (power off) ... –20 °C to + 60 °C
DVD Player
System..................................................... DVD video, Video CD, CD,WMA, MP3, DivX, JPEG
system
Usable discs ............................................ DVD video, Video CD, CD, CD-R/RW, DVD±R/RW/
R DL
Region number ........................................ 4 for Brazil
Frequency response ................................ 20 Hz to 20 kHz (with DVD, at sampling frequency
96 kHz)
Signal-to-noise ratio................................. 75 dB (1 kHz) (IEC-A network) (RCA level)
Output level:
Video ............................................... 1.0 Vp-p/75 (±0.2 V)
Number of channels ................................ 2 (stereo)
MP3 decoding format .............................. MPEG-1 & 2 Audio Layer 3
WMA decoding format ............................. Ver. 7, 7.1, 8, 9, 10, 11 (2ch audio) (Windows Media
Player)
DivX decoding format .............................. Home Theater Ver. 3, 4, 5.2, 6 (.avi, .divx)
DVD video output .................................... NTSC
C
Audio
Continuous power output ... .................... 23 W × 4 (50 Hz to 15 000 Hz, 5%THD, 4
both channels driven)
Load impedance: ..................................... 4 (4 to 8 (2 for 1 ch) allowable)
Preout maximum output level .................. 4.0 V
Equalizer (3-Band Graphic Equalizer):
Frequency ....................................... 80/1k/10 kHz
Gain ................................................. -14 to +14 dB
D
load,
E
F
DVH-840AVBT/XEUW5
5
6
7
8
7
1
2
3
4
Subwoofer (mono):
Frequency ....................................... 80 Hz/120 Hz/160 Hz
Gain ................................................. -79 dB to 0 dB
A
USB
USB standard specification: .................... USB 1.1, USB 2.0 full speed
Maximum current supply ......................... 1000mA
File system: ............................................. FAT16, FAT32
FM tuner
Frequency range: .................................... 87.5 MHz to 108.0 MHz)
Usable sensitivity ..................................... 10 dBµ (S/N: 30 dB)
B
AM tuner
Frequency range: .................................... 531 kHz to 1 602 kHz (9 kHz)
........................................................ 530 kHz to 1 640 kHz (10 kHz)
Usable sensitivity: .................................... 30 dBµ (S/N: 20 dB)
Bluetooth
Version .................................................... Bluetooth 2.0 certified
Output power ........................................... +4dBm Maximum(Power class 2)
Note:
Specifications and the design are subject to modifications without notice.
C
D
2.2 DISC/CONTENT FORMAT
The Bluetooth word mark and logos are owned by the Bluetooth SIG, Inc.
and any use of such marks by Pioneer Corporation is under license.
Other trademarks and trade names are those of their respective owners.
E
F
8
DVH-840AVBT/XEUW5
1
2
3
4
5
6
7
8
3. BASIC ITEMS FOR SERVICE
3.1 CHECK POINTS AFTER SERVICING
A
To keep the product quality after servicing, please confirm following check points.
No.
1
Procedures
Confirm whether the customer complain has
been solved.
If the customer complain occurs with the
specific media, use it for the operation check.
Item to be confirmed
The customer complain must not be
reappeared.
Display, video, audio and operations must be
normal.
2 DVD
Play back a DVD.
(Menu operation; Title/chapter search)
Display, video, audio and operations must be
normal.
3 CD
Play back a CD.
(Track search)
Display, audio and operations must be
normal.
4 FM/AM tuner
Check FM/AM tuner action.
(Seek, Preset)
Switch band to check both FM and AM.
Display, audio and operations must be
normal.
5
Check whether no disc is inside the product.
The media used for the operating check must
be ejected.
6
Appearance check
No scratches or dirt on its appearance after
receiving it for service.
B
For check items concerning image and voice, please refer to the followings:
Check items concerning image
Block-noise
Crosscut noise
Dot noise
Distorted image (Image skip)
Low brightness
Too bright
Color fading
Partial discoloration
C
Check items concerning voice
Distortion
Noise
Low volume
High volume
Changes in level
Pause of sound
D
E
F
DVH-840AVBT/XEUW5
5
6
7
8
9
1
2
3
4
3.2 PCB LOCATIONS
A
B SB SMT UNIT
A:DVH-840AVBT/XEUW5
B:DVH-8480AVBT/XFBR
Unit Number : 843DM7376HRMB003-FY(A)
: CYW1008(B)
Unit Name
: MB Unit
Unit Number : 842DM7376HRSB003-FY(A)
: 882DM7376HBSB003-FY(B)
Unit Name
: SB SMT Unit
KB Ass'y
Consists of
KB PCB
AUX PCB
Unit Number :
Unit Name
: KB Assy
CB/LB Ass'y
Consists of
CB PCB
LB PCB
Unit Number :
Unit Name
: CB/LB Assy
B
A MB UNIT
F LB PCB
C
C KB PCB
E CB PCB
D AUX PCB
D
3.3 JIGS LIST
- Jigs List
Name
21P FFC
Jig No.
GGD1627
Remarks
Mother Unit (MB) - DVD Decode Unit (SB)
E
3.4 CLEANING
Before shipping out the product, be sure to clean the following portions by using the prescribed cleaning tools:
Portions to be cleaned
Cleaning tools
DVD pickup lenses
Cleaning liquid : GEM1004
Cleaning paper : GED-008
1
2
F
10
DVH-840AVBT/XEUW5
3
4
5
6
7
8
3.5 FACTORY SETTINGS
A
- When the Repair is Complete
When the repair is complete, make the DVD mechanism ready for transportation
implementing the following procedures:
1. Attach the two Transportation Screws.
Now you can transport it.(See the figure below)
Transportation
Screws
B
C
D
E
F
DVH-840AVBT/XEUW5
5
6
7
8
11
F
12
1
2
3
C
Display
UART
BT NF2301
MODULE
TEF6606T
TUNER
I 2C
I 2C
L/R
L/R
BT Audio
Operational
AMP
TPA6112A2
L/R
Audio
Processor
TDA7419
NJM2267
D310
D AUX PCB
PAL007E
LINE OUT
Front AV-IN
Power
Amplifier
NJM2792
(4V x 4Ch)
Preamp
L/R
Video out
Rear/Sub
Front
3
KB PCB
PW035XS4 3.5“16:9 TFT
T118FS
LCD Driver
I 2C
NEC uPD78F0547
MCU
I 2C
Video
Preamp
Video
Switch
A
CVBS/Y/C
A/D
SPI
SD RAM
M12L64164A
EN25T16
FLASH
DC 14.4V
2
REMOTE
IR
Panel keys
USB
I 2C
Camera in
Power Supply
B
Y/C
Servo system
Zoran ZR36966H
D5869S
D
PICK UP
E
Motor Driver
A MB UNIT
C
IPOD
Appreciate
341S2162
B SB SMT UNIT
1
4
4. BLOCK DIAGRAM
4.1 BLOCK DIAGRAM
DVH-840AVBT/XEUW5
4
5
6
DVH-840AVBT/XEUW5
7
SA1117 1V8
MAX:800mA
MAX:800mA
8
1A
47 mA
Audio EQ Processor TDA7419
MAX:150mA
5V
BT Audio
Operational AMP
TPA6112A2
SA11173V3
Current Term 5V
1.5A
AP2191D
Video Processor NJM2267M
SA1117
3V3
SA1117
1V8
D5869S
(Motor
driver)
15mA
Video signal switcher BA7613F 20mA
20 mA
Audio Preamp NJM2792
AM FM PLL TUNER TEF6606T 150mA
BT Module
NF2301
AP1507-ADJ
9V
LOD 9V 1A
LSP9801
ADJ
MCU
UPD78F0547 60mA
AGK
Authentication
341S2162-TBB
EN25T16
FLASH
TFT Driver
T118FS
SB Unit
MAX:390mA
Audio DAC
CS4344
SD RAM
M12L64164A
DVD DSP
Zoran
ZR36966H
MAX:500mA
9V
Key illumination
SA1117- 1V8
SA1117-3V3
Operational AMP NJU3414
KB Unit
MAX:200mA
MAX:120mA
MAX:30mA
7
USB Power
Current Term
5V 1.5A
AP2191D
AP1507-ADJ
B+
MCU5V
AMP/ANT control
6
SA1117-3V3
AP1507-ADJ
MAX:3A
MAX:2A
MAX:100mA
LM2950-5V
LOD 9V 1A
LSP9801
ADJ
MAX:1.5A
B+
Current
Term 1.5A
AP2191D
MUTE
Power AMP IC
PAL007E
BATT
+14.4V
5
8
4.2 POWER BLOCK DIAGRAM
A
B
C
D
E
F
13
1
2
3
4
3
4
5. DIAGNOSIS
5.1 OPERATIONAL FLOWCHART
A
Power ON
Battery = 12 V
if Acc on
Acc = 12 V
B
Vcc = 5 V
if Press power on key
DVD Power = 5 V
C
TFT Power
On and TFT
Init
Starts
communication
with Grille
microcomputer.
D
Source keys
operative
Source ON
E
Entery select
mode
operative
Completes power-on operation.
(After that, proceed to each source operation)
F
14
DVH-840AVBT/XEUW5
1
2
5
6
7
8
5.2 ERROR CODE LIST
A
Message
Cause
Action
Loading
Disc is being read
Please wait, it may take several minutes
for some disc or storage device.
Disc is dirty
Clean disc with soft cloth
Disc is upside down
Insert disc with label side up
Disc not present in loading
compartment
Insert disc
Disc is dirty
Clean disc with soft cloth
Disc is upside down
Insert disc with label side up
Unknown disc
Disc format is not compatible
with this unit
Change another disc.
Region Error
DVD is not compatible with
region code of unit
Use discs with corresponding regional
code.
Error
Illegal mechanism operation
Press EJECT key for 5 seconds to reset
loading mechanism
No Disc
Bad Disc
B
C
D
E
F
DVH-840AVBT/XEUW5
5
6
7
8
15
1
2
3
4
(Y ellow)
BT Antenna
Video-out
Camera-in
(Y ellow)
(Black)
Microphone
Radio Antenna
SWC (Steering Wheel Control)
B
Reverse (Active high level input)
Parking SW (Active low level input) (Light
Green/
White)
A
(Pink)
5.3 CONNECTOR FUNCTION DESCRIPTION
C
Fuse 10A
D
19
17
15
13
11
9
7
5
3
1
20
18
16
14
12
10
8
6
4
2
1: FR2: FL+
3: FR+
4: FL5: RR+
6: ILLU_IN
7: RR8: ANT
9: T_MUTE
10: +B
11: RL+
12: GND
13: RL14: LO-FL
15: ACCIN
16: LO-FR
17: GND
18: GND
19: LO/SUB-RR
20: LO/SUB-RL
E
F
16
DVH-840AVBT/XEUW5
1
2
3
4
5
6
7
8
6. SERVICE MODE
6.1 SOFTWARE VERSION INFORMATION DISPLAY
A
Example of a display(AVH-8480AVBT)
MODEL:
MPEG CHIP:
MPEG VERSION:
PCB:V1.0
Disc Region:
MCU DATE:
MCU VERSION:
BT Firmware:
DVH-8480AVBT
ZORAN36966H
V0.24_20111012
4
09.20.11
01.04
V00.46.R00.25
r Model number (UW5 model : DVH-840AVBT)
r Version of MPEG software : V0.24
B
r Region Code of DVD : 4
r Version of MPU software : V1.04
r Version of BT software : V0.46.R0.25
C
D
E
F
DVH-840AVBT/XEUW5
5
6
7
8
17
1
2
3
4
6.2 SOFTWARE VERSION UP METHOD
Save six (6) sorts of file for Version Up (build.img, UPD_MPEG.VER, update.img, UPD_MCU.VER, UPD_BT.VER and
NFOREBT.dfu) on an USB.
Turn the product power to be ON and insert the above mentioned USB.
A
1. MPEG software update
2. MCU software update
3. BT software update (Only a model with BT functional)
4. Reset, "do default setting" in the setting menu.
5. Check Version
Insertion of USB will display the following Update screen.
UW model
B
(Language Setting: Russian for UW5 model)
BR model
C
(Language Setting: Portuguese(B) for BR model)
Method of individual upgrading
Prepare files shown below according to the purpose for upgrading the software. (It is not necessary to prepare all files)
Item to upgrade
MPEG
MCU
BT
D
Use software
build.img , UPD_MPEG.VER
update.img , UPD_MCU.VER
NFOREBT.dfu , UPD_BT.VER
Upgrade the software in the order of MPEG, MCU, and BT.
Please be sure to perform Default Settings in the Setting after performing Version Up.
If you do not perform the Version Up, the initialization of MPEG software will not be executed.
In addition, the Main Body Reset SW located at the rear surface of Detach Panel is only for the Restart RESET
of MCU and it does not mean to perform all of the initializations.
E
F
18
DVH-840AVBT/XEUW5
1
2
3
4
5
6
7
8
1. MPEG update instruction
1. Copy the MPEG update files(upd_mpeg.ver, build.img) to USB device, and insert it to USB Port,
when the system detect the update file exists, it will pop up a menu like Fig.1 as below:
UW5 model
A
BR model
B
Fig.1-1
Fig.1-1
2. If you don’t want to upgrade ,you can press “Cancel” button through Left or Right key of remote control or panel,
otherwise you can move the curse to button “MPEG”, and after pressing Enter key, there will pop other prompt
menu like Fig.2, as below:
UW5 model
BR model
C
Fig.2-1
D
Fig.2-1
3. During the process of upgrade, do not remove the USB device or shut off the power supply, otherwise the system
will breakdown, and never recover any more, if the system restart and pop up Fig.1 for the second time, it means
MPEG upgrade process finished, you can remove the USB device, the whole upgrade process will last about 1 minute;
E
F
DVH-840AVBT/XEUW5
5
6
7
8
19
1
2
3
4
2. MCU update instruction
1. Copy the MCU update files(UPD_MCU.VER, update.img) to USB device, and insert it to USB port,
when the system detect the update file exists, it will pop up a menu like Fig.3, as below:
A
UW5 model
BR model
B
Fig.3-1
Fig.3-1
2. If you don’t want to upgrade, you can press “Cancel” button through Left or Right key of remote control or panel,
otherwise you can move the curse to button “MCU”, and after pressing Enter key, there will pop other prompt menu
like Fig.4, the system start to erase the MCU flash, as below:
UW5 model
BR model
C
D
Fig.4-1
Fig.4-1
3. After erasing process finish, system start to upgrade process, and you will find the upgrade process,
just like Fig.5 as below:
UW5 model
BR model
E
Fig.5-1
Fig.5-1
4. During the process of upgrade, it’s allowed the user to remove the USB device, because system had copied the
update files to SDRAM, this is different from MPEG upgrade, after the process reach 100%, which means MCU
upgrade finished, and the system will power off automatically, you need to press the power key to restart the system,
the whole upgrade process will take around 2.5 Minutes
F
20
DVH-840AVBT/XEUW5
1
2
3
4
5
6
7
8
3 BT update instruction
1. Copy the BT update files(UPD_BT.VER, NFOREBT.dfu) to USB device, and insert it to USB port,
when the system detect the update file exists, it will pop up a menu like Fig.6, as below:
UW5 model
A
BR model
B
Fig.6-1
Fig.6-1
2. If you don’t want to upgrade, you can press “Cancel” button through Left or Right key of remote control or panel,
otherwise you can move the curse to button “BT”, and after pressing Enter key, there will pop other prompt menu
like Fig.7, the system start to erase the BT flash, as below:
UW5 model
BR model
C
D
Fig.7-1
Fig.7-1
3. After erasing process finish, system start to upgrade process, and you will find the upgrade process,
just like Fig.8 as below:
UW5 model
BR model
E
Fig.8-1
Fig.8-1
4. During the process of upgrade, it’s allowed the user to remove the USB device, because system had copied the
update files to SDRAM, this is different from MPEG upgrade, after the process reach 100%, which means BT
upgrade finished, and the system will power off automatically, you need to press the power key to restart the system,
the whole upgrade process will take around 2.5 Minutes
DVH-840AVBT/XEUW5
5
6
7
8
F
21
1
2
3
4
4. Upgrade of software is completed
If upgrade of software is completed, please perform Default setting by Seetting Menu.
A
NOTE:
Item to upgrade
Only MPEG
MPEG => MCU
MPEG => MCU => BT
MCU => BT
Only MCU
Only BT
Method
USB device is extracted in the state of an Version UP display.
1. USB device is extracted after automatic power switch OFF.
2. Power switch is turned ON.
3. Default setting is performed by Seetting Menu.
-Seetting Menu
UW5 model
B
BR model
C
How to check the software version, the detailed operation method will be showed as below:
1) Enter into Seetting Menu;
2) Press "5" "4" "3" "2" numeric key on the remote controll
You will find the version information; to exit the version menu, please press "ESC" key
D
E
F
22
DVH-840AVBT/XEUW5
1
2
3
4
5
6
7
8
7. DISASSEMBLY
Removing the Top Cover and the Bottom Cover (Fig.1)
1
2
A
Bottom Cover
Remove the screw and then
remove the Bottom Cover.
1
Remove the screw and then
remove the Top Cover.
2
Top Cover
B
Fig.1
Removing the Deck (Fig.2)
1
Remove the two screws.
2
Remove the two screws.
C
3
Disconnect the connector and then remove
the Deck.
1
1
D
Deck
2
2
E
3
F
Fig.2
DVH-840AVBT/XEUW5
5
6
7
8
23
1
2
3
4
Removing the Cabinet (Fig.3)
A
B
4
1
Disconnect the two connectors.
2
Remove the screw.
3
Remove the two screws.
4
Release the two latches and then remove
the Cabinet.
3
2
3
4
Cabinet
1
1
C
Cabinet
Fig.3
Removing the MB Assy (Fig.4)
2
D
E
1
Remove the two screws.
2
Remove the four screws and then remove
the Heat Sink.
3
Fix the nut for fixing a screw not to rotate,
and then remove the screw.
4
Remove the solder at three locations
indicated and then straighten the tabs.
5
Remove the two screws and then remove
the MB Assy.
2
3
2
1
1
2
Heat Sink
4
4
5
4
5
F
MB Assy
Fig.4
24
DVH-840AVBT/XEUW5
1
2
3
4
5
6
7
8
- How to eject the stuck disc (Procedure 1: Rotating the roller)
A
1
Remove the screws.
2
Remove the top and the bottom cover.
B
3
Remove the screws.
4
Remove the DVD
mechanism module.
5
Rotate the gear upward.
C
D
E
Then, the disc will be ejected.
F
DVH-840AVBT/XEUW5
5
6
7
8
25
1
A
2
3
4
- How to eject the stuck disc (Procedure 2: Removing the top cover)
1
Remove the screws.
2
Remove the top and the bottom cover
of the product.
3
Remove the screws.
4
Remove the DVD
mechanism module.
5
Remove the screws.
6
Remove the dustproof
cover.
7
Remove the screws.
B
C
D
E
Left side
F
26
Top
Right side
DVH-840AVBT/XEUW5
1
2
3
4
5
8
Remove the top cover of
the DVD mechanism.
9
Lift up the clamp holder,
and remove the disc.
6
7
8
A
B
C
D
E
8. EACH SETTING AND ADJUSTMENT
There is no information to be shown in this chapter.
F
DVH-840AVBT/XEUW5
5
6
7
8
27
1
2
3
4
9. EXPLODED VIEWS AND PARTS LIST
NOTES : Parts marked by " * " are generally unavailable because they are not in our Master Spare Parts List.
The > mark found on some component parts indicates the importance of the safety factor of the part.
Therefore, when replacing, be sure to use parts of identical designation.
Screw adjacent to mark on the product are used for disassembly.
For the applying amount of lubricants or glue, follow the instructions in this manual.
(In the case of no amount instructions,apply as you think it appropriate.)
A
"
9.1 PACKING
B
C
D
E
F
28
DVH-840AVBT/XEUW5
1
2
3
4
5
6
7
8
(1) PACKING SECTION PARTS LIST
Mark No.
Description
Mark No.
Part No.
Description
Part No.
1
Brown
2
Polyethylene Bag
127025020001-FY
See Contrast table (2)
11
Rim
141270000509000-FY
3
Unit Box
See Contrast table (2)
12
Screw(M5 x 6)
121100070063-FY
4
Contain Box
See Contrast table (2)
13
Bolt
121050000003-FY
5
Side Key
121090000327-FY
14
Cushion
121410000026-FY
6
Pulp Foam
127015000249-FY
7
Pulp Foam
127015000250-FY
8
Case Assy
883DM7376HBFJ000-FY
9
Power Cord (Assy)
883DM7376HPWR004-FY
10
Card Type RC
See Contrast table (2)
*
15-1 Warranty Card
See Contrast table (2)
15-2 Owner's Manual
See Contrast table (2)
*
15-3 Service Network
16
Microphone Assy
See Contrast table (2)
123650000003-FY
(2) CONTRAST TABLE
DVH-840AVBT/XEUW5 and DVH-8480AVBT/XFBR are constructed the same except for the following:
Mark
No.
Description
DVH-840AVBT/XEUW5
A
B
DVH-8480AVBT/XFBR
*
2
3
4
10
15-1
Polyethylene Bag
Unit Box
Contain Box
Card Type RC
Warranty Card
*127060020025-FY
127020002817-FY
127000002581-FY
CXE5124
127070008002-FY
127060000025-FY
127020002816-FY
127000002382-FY
CXE5125
Not used
*
15-2
15-3
Owner's Manual
Service Network
127075003546-FY(Russian)
Not used
127075003547-FY(Portuguese(B))
CRY1227
C
D
E
F
DVH-840AVBT/XEUW5
5
6
7
8
29
1
2
3
4
9.2 EXTERIOR (1)
A
B
A
C
C
D
A
D
E
F
30
DVH-840AVBT/XEUW5
1
2
3
4
5
6
7
8
(1) EXTERIOR (1) SECTION PARTS LIST
Mark No.
Description
Mark No.
Part No.
Description
Part No.
1
Detach Panel
See Contrast table (2)
18
Button(POWER)
141230303269018-FY
2
Lens
See Contrast table (2)
19
Double Side Tape
121445000246-FY
3
Cover
141290002380000-FY
20
Button(Four Point)
141230003268018-FY
4
Panel
141210001357000-FY
5
Button
141230003270000-FY
21
Button Bracket
141240001197000-FY
22
Button(BSM)
141230303267018-FY
6
Spring
121035000332-FY
23
Button(OK/ESC)
141230303273018-FY
7
Cover
141000002907-FY
24
Guide
141260000657000-FY
8
TFT/A
143420020032-FY
25
Mat
121405000245-FY
9
Bracket
141240001196000-FY
10
Spring
121035000136-FY
26
Sponge
121405000260-FY
27
•••••
11
Slide Block
14129080071400-FY
28
Slide Block
14129080071300-FY
12
Lens
141220300548018-FY
29
Panel
141210001358000-FY
30
Screw(M2 X 10)
121040000184-FY
31
Power Cord (Assy)
883DM7376HPWR004-FY
32
Card Type RC
See Contrast table (2)
33
Cover
141272000043-FY
13
Double Side Tape
121445000250-FY
14
Knob
141230502986017-FY
15
Spring
121035000569-FY
16
Button(BAND)
141230303271018-FY
17
Button(SRC)
141230303272018-FY
A
B
(2) CONTRAST TABLE
DVH-840AVBT/XEUW5 and DVH-8480AVBT/XFBR are constructed the same except for the following:
Mark
No.
Description
1
2
32
Detach Panel
Lens
Card Type RC
DVH-840AVBT/XEUW5
843DM7376HRKB004-FY
141220600587028-FY
CXE5124
C
DVH-8480AVBT/XFBR
CXE5350(Grille Assy)
141220600587018-FY
CXE5125
D
E
F
DVH-840AVBT/XEUW5
5
6
7
8
31
1
2
3
4
9.3 EXTERIOR (2)
A
B
A
B
B
A
D
C
C
H
E
F
F
G
D
E
D
B
E
A
C
F
G
E
H
F
32
DVH-840AVBT/XEUW5
1
2
3
4
5
6
7
8
(1) EXTERIOR (2) SECTION PARTS LIST
Mark No.
Description
Mark No.
Part No.
Description
Part No.
1
Screw(M2.6 X 5)
2
Screw(M2.6 X 5)
121040000054-FY
121106070011-FY
31
Screw(M3 x 8)
121100070059-FY
3
Panel Assy
883DM7376HBZJ000-FY
32
Heat Sink
121015010165-FY
4
Gear
141200010082-FY
33
Screw(M2.6 x 12)
121104070026-FY
5
Damper
121200000831000-FY
34
Bolt
121050000003-FY
35
Cushion
121410000026-FY
6
Screw(M2 x 4)
121104080020-FY
7
Washer
121440000031-FY
36
Short Sheet
141000002864-FY
8
•••••
37
Screw(M2.6 x 8)
121101050013-FY
9
Bracket
141000003115-FY
38
Screw(M2.6 x 8)
121104070008-FY
10
Screw(M2 x 5)
121040000185-FY
39
Screw(M2 x 4)
121104050032-FY
40
Shield Cover
141000002742-FY
11
Button(EJECT)
141230301924018-FY
12
Dustproof
121450000126-FY
41
Heat Silica Gel
121490000426-FY
A
B
13
Frame
141000002908-FY
42
SB SMT Unit
See Contrast table (2)
14
Sponge
121405000004-FY
43
Deck
144840020083-FY
15
Cover
141000001855-FY
44
Mat
121410000025-FY
45
Dustproof Cover
121450000209-FY
121405000032-FY
16
Insulator
121415000189-FY
17
Mat
121405000040-FY
46
Mat
18
Screw(M2.6 x 5)
121103070004-FY
47
Bracket
141000002909-FY
19
Screw(M2.6 x 5)
121104070007-FY
48
Dustproof
121450020132-FY
20
MB Assy
See Contrast table (2)
49
Cover
141000002906-FY
50
Wire Harness
123835000874-FY
C
21
Heat Silica Gel
121490000771-FY
22
Heat Silica Gel
121490000464-FY
51
FFC
123820010189-FY
23
Heat Sink
141010000496-FY
52
DVD Mechanism Module
See Contrast table (2)
24
Bracket
121000000319-FY
53
FFC
123820000486-FY
25
Spring
121035010571-FY
54
FFC
143820000257-FY
55
I/O
123830001333-FY
123830011242-FY
26
Bracket
141000031662-FY
56
I/O
57
Fuse(10 A)
144800000076-FY
141290001281018-FY
58
Screw
?????
121050000023-FY
59
Cover Ass'y
883DM7376COVER000-FY
27
Locker
141290001280018-FY
28
Spring
121035000572-FY
29
Handspike
30
Nut
>
D
(2) CONTRAST TABLE
DVH-840AVBT/XEUW5 and DVH-8480AVBT/XFBR are constructed the same except for the following:
Mark
No.
Description
20
42
52
MB Assy
SB SMT Unit
DVD Mechanism Module
DVH-840AVBT/XEUW5
843DM7376HRMB003-FY
842DM7376HRSB003-FY
843DM7376HRSB003-FY
DVH-8480AVBT/XFBR
CYW1008
882DM7376HBSB003-FY
883DM7376HBSB003-FY
73
E
F
DVH-840AVBT/XEUW5
5
6
7
8
33
1
2
3
4
10. SCHEMATIC DIAGRAM
10.1 MB UNIT (1/2) (GUIDE PAGE)
A
Note: When ordering service parts, be sure to refer to " EXPLODED VIEWS AND PARTS LIST" or
"ELECTRICAL PARTS LIST".
A-a
A-a
A-a
A-b
A-a 1/2
Large size
SCH diagram
A-b
Guide page
Detailed page
A-b
B
C
D
E
F
A 1/2
34
DVH-840AVBT/XEUW5
1
2
3
4
5
6
7
8
A
A-b 1/2
B
C
D
E
F
A 1/2
DVH-840AVBT/XEUW5
5
6
7
8
35
D417
MVS0603M04
1K
R482
R492
1K
R460
100R
4
W_LED [1]
C859
100nF
USB_5V
100nF
C819
D404
D403
D402
D401
IN4148
IN4148
IN4148
IN4148
[1]
3
2
1
33pF
NM
33pF
GND
KEYAD
KEYD
FY/CON3P-90-2.0
C860
22uF/16V
DVD_5V [1]
A 2/2
1K
R801
Q801
,DMP3098
R802
D5V [1,2]
4.7K
CN404
C476 C477
NM
USB_5V
B+
4
5
Q406
OUT
LED-5V [1]
DVD_Y+
YC_GND
DVD_C+
YC_GND
CN203
1
2
3
4
33pF
KRA102S
Q415
KIN1 [1]
1K
33pF
C256
[1] W-LED
10nF
R219
A 2/2
R458
100R
MCU10 [1]
R489
1K
R459
43K
C863A
10uF
0R
100uF/16V
6P-1.0mm
RESET
DTH_SW
W-LED
LED-5V
GND
EJECT
YOUT [1]
F
R883
10K
A-a A-b
10K
R884
MCU68 [1]
CN406
C805
100nF
CON406
C804
COUT [1]
6
5
4
3
2
1
DVD_POWER [1,2]
R220 0R
R216
C863
10uF
C806
R217
C408
1nF
MCU58 [1]
R485
LED-5V [1]
3
2
1
Q813
BD435
C255
FLG
GND
TO SERVO
W_LED [1]
KRA102S
EN
IN
U804
AP2191D
C822
100nF
470R
R863
R862
R861 R860
10K 10K
Q802
KRC231
R804B
2.2R
R804A
2.2R
C803
22uF/16V
C420
0.22F/5.5V
R821
DVD_5V
R827
8.2K
R830
8.2K
12
F/16V
1nF C400
C818
1000uF/16V
R10
ZD804
AZ431AN-ATRE1
100nF C862
R806
39K
R807
15K
C413
100nF
WIRE_REMOTE
FU802
NM
R882
1812/NC
R515
22K
R514
12K
Q503
PMBT3904
MCU36 [1]
D510
MVS0603M04
MCU53 [1]
D511
MVS0603M04
MCU65 [1]
4.7K
MCU5V
R454
47K
C450
1nF
100R
C858
1000uF/16V
R452
47K
R455
47K
R453
47K
100nF C861
D5V
R509
C501
100nF
R517
1M
D5V
100R
NM
C550
2.2uF
R518
47K
Q502
PMBT3904
R510
USB
R525
10K
D5V
100nF
C520
R526
47K
C511
100nF
R516
47K
R511
220K
1K
30K
R881
5
6
7
8
C882
100uF/16V
100pF
C881
U809
LSP9801
4
VCC
OUT
3
EN
OUT
2
FB
OUT
1
GND
OUT
R508
A-b 1/2
C502
3
U06
DVH-840AVBT/XEUW5
2.2uF
47K
2
47K
1
D9V
R512
22K
D505
IN4148
D504
IN4148
3.3V
R530
22K
47K
R502
D503
IN4148
33pF
C504
A 2/2
D502
IN4148
R503
1K
[1,2]
D- [1]
D+ [1]
A 2/2
T_MUTE [2]
D5V
33pF
C505
PARKING
CAMERA-IN
A 1/2 MB UNIT(1/2)
ZD503
36
5.1V/300mW
F
R513
E
D507
1
2
CN501
A
10K
D
3
MVS0603M04
C
R504
B
2
D506
MVS0603M04
1
4
7
7
28
Q409
PMBT3904
R422
1K
R418
1M
8M
5
C403
22pF
X402
D439
MVS0603M04
C407
100nF
R499
2.2K
R498
C404
22pF
R497
10K
5V
R457
C406
100nF
10K
10K
C401
12pF
32.768K
[2]
ACC_ON [1]
ILLU_IN
C402
12pF
A 2/2
LED-5V [1]
Q414
MMBT3904
KRA102S
Q415
33pF
R466
22K
33pF
C256
MCU25 [1]
D5V
Q411
KRA102S
5V
MCU66 [1]
R520
10K
Q410
KRC231
Q413
KRA102S
10K
3 OUT IN 2
U501
D7035
R519
Q412
PMBT3904
A-a A-b
A/D 20V power off
R523
100k
NM
B+
5.6K
3V3
ZD502
low power off
R521
6.2K
MCU47 [1]
6V8
ZD402
R462
R812
47K
MVS0603M04
D433
C416
100nF
R813
4.7K
Q807
KRC231
R814A
C415
100nF
D419
IN4148
NM
C550
2.2uF
R984
1K
NC/1K
C810
100nF
D802
1N4001
D801
1N4001
NC/0R
R850
R840
0R
R814
2.2R
0R
D505
IN4148
MCU08 [1]
R461
R461A
D506
MVS0603M04
[2]
D5V [1,2]
ANT [2]
AMP_ANT
A 2/2
ACCIN
[2]
NC : No Mount
: The power supply is shown with the marked box.
NOTE :
Symbol indicates a resistor.
No differentiation is made between chip resistors and
discrete resistors.
Symbol indicates a capacitor.
No differentiation is made between chip capacitors and
discrete capacitors.
B+[1,2]
C
2.2uF
Q806
DMP3098
A 2/2
B+ [1,2]
5V [1,2]
FU801
1812
C417
2.2uF/50V
R517
1M
7
A-b 1/2
D440
MVS0603M04
X401
D437
MVS0603M04
4
D438
MVS0603M04
NM
D431
W_LED [1]
MVS0603M04
IN4148
D432
D404
MVS0603M04
U06
D434
IN4148
MVS0603M04
IN4148
D435
C255
D436
D403
[1] YOUT
MVS0603M04
R465
5.6K
[1] MCU37
R464
100K
D555
MVS0603M04
D402
D430
MVS0603M04
[1]COUT
MVS0603M04
DVH-840AVBT/XEUW5
D508
MVS0603M04
6
C503
100nF
10K
R463
R522 7.5K
D507
IN4148
R217
ZD501
6V8
MVS0603M04
D401
GND
1
6
R524
D418
IN4148
5
10K
5
8
A
B
C
D
E
8
37
F
[1]ACC_ON
C143
10nF
NC
TX
RX
FLDMO
RESET
VDD
1
7
6
5
4
3
2
10nF
R103
L106
L102
DVD_POWER [1,2]
5V
C129
100nF
3.3uH
100R
390nH
U101
FET6606T
C142
100nF
R131
1K
R130
1K
10UH
A 2/2
MCU51 [1]
MCU50 [1]
MCU5V
L107
C141
5
D101
IN4148
SDA
IN4148
D102
ANT101
D103
MVS0603M04
GND
CN401
C144
10pF
GND
ANTENNA
4
3 A2
A1
8
L108
32
VCC
L105
560UH
D413
IN4148
D5V
MCU22 [1,2]
MCU21 [1,2]
L104
560UH
C128
33pF
150nH
L103
C145
7
U103
WP
FT24C02A3
6
SCL
R127
470K
30
AMIFAGC1
C146
10nF
A 2/2
C120
100nF
A0
C119
MCU13
MCU10
MCU5V
MVS0603M04
D445
Q408
KRA102S
RES_MUTE [2]
A 2/2
C140
15nF
20
R104
2.2uF
MCU53
MCU54
MCU55
MCU56
MCU57
18
C113
22pF
2.2uF
MCU58
C115
C130
15nF
C116
C117
C122
100nF
R102
1K
4.7K
R106
4.7K
R105
4M
C114
22pF
R101
X101
2R2
53
54
55
56
57
58
59
60
10K
MCU21 [1,2]
R476
LIGHT-SW
Y/C_CTL
(DVD5V)
K5V
DTH_SW
AVREF
AVSS
A 2/2
TUN_R [2]
TUN_L [2]
A 2/2
D9V
MCU22 [1,2]
C109
100uF/16V
1K
C110
100nF
R117
MCU69
2
R128
470k
31
AMOUT2
AMRFDET
1
AMOUT1
AMRFIN
2
28
AMIN1
1uF C124
29
4
FMIN2
10nF
AMIN2
R415
27
TEST
6
C126
470nF
C118
100nF
23
C121
VCC8V5
26
VCOREF
AMRFAGC
7
C125
470nF
22
VCC8V52
10nF
R129
4.7K
25
VCOLOOP
8
21
VREGSUP
100nF
19
10nF
24
VCCVCO
ROUT
9
GNDANA
GNDAUD
10
AMIFAGC2
11
470nF
17
GNDDIG
XTAL1
MCU26 [1]
B+
MCU26 [1]
B+
B+
Q804
KRC231
L824
100UH
R819
47K
L819
100UH
R460A
R460B
Q810
KRC231
100R
100R
R824
MAIN MCU
D405
1N4001
MCU63
C854
10uF
1K
MATO1/W_LED
MAT00/NAV_CTL
MATI3
MATI2
MATI1
MATIO
EXLVI
D5V
R490
100uF/25V
C856
1
5
1 R480
8
7
6
5
4
3
2
3
2
4
1K
Q418
MMBT3906
MCU[00:80]
5
U803
AP1507-ADJ
USB 5V
3
2
4
C410
100uF/16V
OUT
U402
LM2950-5V
DVD 5V
IN
U802
AP1507-ADJ
100uF/25V
C816
1
C409
100uF/25V
D406
1N4001
GND
1
MCU74
A-a A-b
47K
33R
MPXIN
12
C123
D5V
MCU08
5V
C857
100nF
L803
100UH
R826
R827
8.2K
1K
R482
R492
1K
MCU06
D417
MVS0603M04
620R
100nF
C817
200R
R460
100R
C420
0.22F/5.5V
W_LED [1]
C859
100nF
USB_5V
100nF
C819
R821
DVD_5V
C413
100nF
MCU5V
A-b 1/2
R830
8.2K
C412
100uF/16V
L401
10uH/15mA
L801
100UH
R841
C411
100nF
MCU06
5V
R842
2.7K
VREF4V0
MPXOUT
13
MUX
SDA
RSSI
14
SCL
XTAL2
15
GNDRF
5
C127
33pF
3
R413
47K
R108
22K
FMIN1
10K
C414
2.2uF
47K
R107
22K
C103
1nF
R477
10K
LOUT
R486
MCU68
C814
MCU76
10uF
MCU78
78
16
47K
R428
MCU79
79
C104
1nF
R474
MCU62
62
KI1
MCU61
61
KI0
MCU63
63
KEYD
64
BAND SELECT
MCU66
R430
66
B+_DET
MCU65
65
(CAMERA_DET)
1K
67
KEYAD
68
(USB_CTL)
MCU69
69
TFT_RESET
MCU70
70
(CHUCK_SW)
MCU72
72
(LOAD_SW)
MCU71
71
(EJECT_SW)
MCU73
73
(DVD_EN)
74
(DISC_EJECT)
C855
100nF
C815
76
(DATA_IN)
MCU75
75
(DVD_REST)
1K
R475
MCU80
R495 10K
80
R491
10K
D806
B360B
D803
B360B
ZD405
NC/6V8
R825
2.7K
D400
MVS0603M04
R820
100R
C818
1000uF/16V
100R
C858
1000uF/16V
100nF
MCU77
77
(DVD_DATA)
4
(DVD_CLK)
DVH-840AVBT/XEUW5
BEEP
F
CTL-A
D404
D403
D402
D401
3
K
MCU13
R429
10K
ZD401
NC/6V8
3
R452
2
47K
1
R454
38
C450
A-a 1/2
47K
C
1nF
E
1nF C400
D
R453
B
R10
A
2
47K
1
4
D9V
R251
4.7K
R250
1K
Q205
KRC231
R414
10K
560R
0R
100R
100R
100R
100R
100R
0R
560R
4
5
Q204
KRC231
OUT
FLG
GND
R271
ZD205
R270
EN
IN
U403
AP2191D
DVD_POWER
R416
R473
10K
5V
Q401
KRA102S
CDP_R [2]
CDP_L [2]
R412
R468
R403
R404
R405
R406
R407
R401
R467
C812
100uF/16V
R831
0R
R413
47K
A 2/2
R409
100R
100nF
C811
R487
Q201
KRC231
COCLOUR [1]
LAMP [1]
C405
LAMP [1]
C473
22uF/16V
[1] USB_5V
+5V_M
A 2/2
10R
M_BT_RX [2]
M_BT_TX [2]
Q206
DMP3098
25
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
Illumination control
MCU52 [1]
CN6
B 1/2
DATA_IN
RESET
DVD_8V
DVD_8V
DVD_5V
DVD_5V
DVD_CLK
D+
CHUCK_SW
EJECT_SW
LOAD_SW
EN
EJECT
DDVD_DATA
GND
GND
CDP_L
A_GND
CDP_R
K5V
GND
B-BT-RX
GND
B-BT-TX
CON201
DVD_POWER [1,2]
A 2/2
100nF
C474
100nF
D9V
5V6
4.7K
47K
3
2
1
R242
NM
R275
R2741K
R272
R494
BEAD
NM
47K
100
0.5W
BLUE
[1]
35
100
0.5W
USB-POWER [1]
C451
100uF/16V
TFT_5V [1]
MCU57
MCU45
MCU77
MCU45
MCU46
MCU47
MCU70
MCU71
MCU72
MCU73
MCU74
MCU49
MCU50
MCU51
MCU52
MCU53
MCU48
MCU76
MCU75
MCU54
MCU55
MCU56
MCU78
MCU5V
MCU57
MCU58
D5V
ASF
47K
10K
SSTOP
SW_FLAG
(TFT_5V)
REMOTE
(power on)
(DVD9V_SW)
(BT/TV_ON)
(GPS_RXD)
(GPS_TXD)
LAMP SW
CAMERA-IN1
LIGHT-SW
Y/C_CTL
(DVD5V)
K5V
DTH_SW
(DV
(CHUC
(US
8
E
UPD78F0547
U401
MAIN MCU
A 2/2
CON2
(DVD_
MCU24 [1]
MCU23 [1]
EXLVI
R440
R441
47K
NM
R420
R419
EVDD
VDD
EVSS
VSS
REGC
X1/OCDOA
X2/EXCLK/OCDOB
FLMD0
XT1
EXCLK1
RESET
USB-POWER
ANT CTL
MATO1/W_LED
MAT00/NAV_CTL
MATI3
MATI2
MATI1
MATIO
20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
5.6K
5.6K
1 R480
FY/CON34P-1.0SMT-90AAAAA
CN402
36
MCU15
MCU14
MCU13
MCU10
MCU09
MCU08
MCU06
MCU5V
2.2uF
100R
MCU5V
C419
R417
1K
MCU27
MCU28
Q409
PMBT3904
R422
1K
R418
1M
8M
C403
22pF
X402
MCU14
W_LED [1]
MCU15
MCU06
R
C
2
C407
100nF
R499
2.2K
D404
D403
D402
D401
A-b 1/2
7
A-a A-b
R402
R496
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
AVREF
AVSS
(LED_C/F_DET)
60
59
BAND S
37
D445
MVS0603M04
DMP3098
Q403
Q402
KRC231
D- [1]
D+ [1]
R451
1K
7
C249
100nF
C414
2.2uF
R450
47K
1K
R273
NC
Q202
KTC8550
R486
10K
TFT_RE
(COLOUR)
MCU50 [1]
[1]RED
C475
100nF
47K
R426
(EJEC
(TFT_DATA)
MCU51 [1]
Q203
KTC8550
47K
R425
+5V_M
39
MCU39
RDS_DAT
MCU40
(DVD_
(EN_B)
5
TFT_CS [1]
47K
R424
LED_C [1]
2
F_DET1
3
TFT_DATA
1
+5V_M
TFT_DATA [1]
R532
MCU54 [1]
100R
TFT_CLK [1]
4
LIGHT-SW
5
TFT_CLK
6
REST/CS
EN_B [1]
7
EN_B
EN_A [1]
8
EN_A
38
MCU30
CTL-B
MCU23
1K
R431
[1]EN_B
1K
R432
40
[1]EN_A
9
GND
KIN1 [1]
10
KIN1
MCU24
[1]TFT_DATA
1K
R433
[1]TFT_CLK
REM [1]
12
REM
KIN0 [1]
11
KIN0
(CAMER
TEL_MUTE
36
MCU36
B+
T118B REST
MCU33
MCU37
MCU31
1K
R434
[1]TFT_CS
100R
R435
[1]LED_C
14
LAMP [1]
TFT-LIGHT
34
MCU34
LIGHT
RED [1]
13
RED
35
MCU35
MCU37
1K
R423
TFT_CS
33
MCU33
MCU35
32
1K
MCU34
R408 1K
[1] T118-REST
TFT_5V [1]
1K
R437
17
CVBS1
16
+5V_TFT
[1]TFT-LIGHT
15
GND
(DISC_
ACC_IN
27
(DAT
LOW CHECK
25
(DVD
(EN_A)
23
(LOA
A_MUTE
29
MCU29
(TFT_CLK)
31
MCU31
MCU62
MCU32
MCU32
R483
COCLOUR [1]
CVBS_OUT3 [2]
W-LED [1]
1K
R438
19
GND
18
W-LED
YOUT [1]
20
DVD_Y
30
MCU30
MCU61
1K
R439
28
MCU28
COUT [1]
MCU27
ILLU_IN
MCU46
100R
R427
21
GND
22
DVD_C
SCK
21
MCU21
(DVD_5V)
26
MCU26
[1] KIN0
F_AUX_L [2]
24
MCU24
F_AUX_R [2]
22 SDA
MCU22
FAV_CVBS [2]
[1]REM
23
GND
T118-REST [1]
MCU25
AUX_L
TFT-LIGHT [1]
D444
MVS0603M04
R411
6
31
R442
10K
BLUE [1]
24
[1]KIN1
25
GND
26
AUX_R
MCU23
27
GND
28
CVBS2
29
T118B REST
30
TFT-LIGHT
D+ [1]
D+
32
BLUE
D- [1]
33
R443
10K
USB-POWER [1]
34
7
D-
R410
6
USB5V
DVH-840AVBT/XEUW5
NM
6
100K
TX
D439
MVS0603M04
RX
D440
MVS0603M04
5
D438
MVS0603M04
5
8
A-a 1/2
39
A
B
C
D
E
F
1
2
3
4
3
4
10.2 MB UNIT (2/2) (GUIDE PAGE)
A
A-a 2/2
B
C
D
E
F
A 2/2
40
DVH-840AVBT/XEUW5
1
2
5
6
7
8
A
A-b 2/2
B
C
D
E
F
A 2/2
DVH-840AVBT/XEUW5
5
6
7
8
41
42
1
IN2
2
3
100nF
C213
22uF/16V
100uF/16V
C214
100nF
C212
R215
75R
NC
NC
R218
75R
R214
C203
100nF
R213
[1]
[1]
MCU39
5
6
MCU80
GND
IN3
C312
1.5nF
D9V
LO_FL
LO_FR
DVH-840AVBT/XEUW5
4
RES_MUTE [1]
MCU29 [1]
5V [1]
A 1/2
LINE/SUB-RL
LINE/SUB-RR
D303
IN4148
Q303
KRA102S
100R
390R
2.2uF/16V
R326
22K
R327
22K
2.2uF/16V
R331
22K
R341
22K
22uF/16V
22uF/16V
R321
R320
D310
IN4148
C314
C315
C316
C317
C313
100uF/16V
R324
R328
R330
R342
R322
100K
470R
470R
470R
470R
R323
10K
Q304
MMBT3906
A-a A-b
Q309
KRC231
Q306
KRC231
R325
Q307
KRC231
R329
Q308
KRC231
R340
R343
100R
100R
100R
100R
P-MUTE
[2]
Q311
KRC231
Q310
KRC231
LO-FL
[2]
LO-FR
[2]
LO/SUB-RL
[2]
LO/SUB-RR
[2]
C325
C326
33pF
33pF
C320
C321
33pF
33pF
A 2/2 MB UNIT(2/2)
3
LINE/SUB-RR
LINE/SUB-RL
CVBS_OUT3
[1]
A 1/2
V_OUT
[2]
C204
100uF/16V
R206
100R
V_IN [2]
E
100uF/16V
C211
8
VCC 7
A 1/2
CTLB
C210
22uF/16V
4
3
2 CTLA
VOUT
U202
BA7613F
1 IN1
D
C215
F
F
A-b 2/2
C
R317 39K
B
R318 33K
A
2
D205
MVS0603M04
1
4
RL-FB 18
FL-OUT
RL OUT
L-CONT
16
R317 39K
17
33pF
LINE/SUB_L [2]
D5V
C942
100nF
D9V
C964
33pF
C963
33pF
MCU21 [1]
MCU22 [1]
10R R971
C966
33pF
33pF
RF
RR
LR
LF
LO_FL
LO_FR
C965
A 1/2
NJM2792
U301
LF
RF
LR
RR
RES_MUTE [1]
D303
IN4148
2.2uF
C946
R956
2.2uF
2.2uF
C945
C947
2.2uF
100R
C944
R320
P-MUTE [2]
Q303
KRA102S
470K
8.2K
R946
R941
10K
Q907
PMBT3904
8.2K
470K
R943
470K
8.2K
R939
R945
470K
R942
R940
8.2K
R938
C313
100uF/16V
47K
C930
C926A
1uF
NC
1uF
C929
NC
C925A
1uF
1uF
C928
NC
C924A
C927
NC
C923A
47K
R936
R323
10K
C948
470nF
22K
1uF
22K
1uF
22K
1uF
A-a A-b
R954
R983
R982
R950
C926
R949
C925
R948
C924
R947
1uF
22K
R937
10K
C923
100nF
C922
R322
100K
A 1/2
IN2
12
MUT
IN4
C917
1uF
22
14
15 IN3
13
IN1
11
MCU79 [1]
A 1/2
8
FL
FR
RL
RR
5
17
25
3
OUT4-
C919
2.2uF
C919A
2.2uF
21
19
C978
33pF
C971
33pF
C979
33pF
C980
33pF
C981
33pF
U903
PAL007E
23
FL SPK
OUT4+
OUT3-
FR SPK
OUT3+
N.C
OUT2-
RL SPK
OUT2+
RR SPK
7
OUT1-
OUT1+
9
FL- [2]
FL+ [2]
FR- [2]
FR+ [2]
RL- [2]
RL+ [2]
RR- [2]
RR+ [2]
33pF
100nF
C322
C323
33pF
B+
C984 33pF
C983 33pF
C982 33pF
C985
RR+ [2]
FR+ [2]
FL- [2]
FU901
1812
RL- [2]
B+
20
19
18
17
16
15
14
13
12
11
22
21
10
9
8
7
6
5
4
3
2
1
33pF
33pF
33pF
33pF
33pF
CM700,20PIN
CN901
The > mark found on some component parts indicates
the importance of the safety factor of the part.
Therefore, when replacing, be sure to use parts of
identical designation.
C920
100nF
LO/SUB-RL [2]
FR- [2]
C329
C328
C327
C326
C325
FL+ [2]
RL+ [2]
1.1 A >
LO-FR [2]
LO-FL [2]
RR- [2]
LO/SUB-RR [2]
ACCIN [1]
AMP_ANT [1]
T_MUTE [1]
ANT [1]
ILLU_IN [1]
A 1/2
100nF
33pF
C321
C324
33pF
C320
7
A-b 2/2
GND
C961
R968
R969
1K
R967
33pF
R318 33K
[2] LINE/SUB_R
22uF/16V
4.7K
1K
100uF/16V
C943
C941
C962
T CIRCUITRY
3
RL-IN
FL-FB
4
R313
V+
14
RR-FB
15
6
FL-IN
5
39K
RR-IN
REF
13
RR-OUT
FR-FB
8
33K
R314
11
R-GND
12
R-CIN
FR-OUT
9
R-OUT
10
C305
FR-IN
7
C303
100uF/16V
100uF/16V
MCU29 [1]
33pF C967
1
TAB
2
10
S-GND
ST
4
GND
18
VCC
6
GND
ACG
16
SVR
C918
GND
24
GND
VCC
20
LINE/SUB-RR
C970
P-MUTE
[2]
D-TVS
R321
D902
D310
IN4148
C986
33pF
5V [1]
C968
33pF
C972
33pF
Q304
MMBT3906
7.5K
R951
D9V [1,2]
R952
10K
7
47uF/16V
C973
33pF
390R
C921
C975
A 1/2
3300uF/16V
C974
33pF
IN5401
C976
33pF
C312
1.5nF
100nF C969
DVH-840AVBT/XEUW5
33pF
6
D901
C977
33pF
6
33pF
FUSE
5
>10 A
5
8
A
8
B
C
D
E
43
F
POWER SUPPLY
A 1/2
47K R720
BT_3V3
BT_1V8
BT_RX
[1] M_BT_RX
[1] M_BT_TX
BT_TX
C704
2.2uF
C702
C703
2.2uF
470R
R702
R703
0R
0R
16
18
17
15
SDO
14
BT_CE
13
SDI
12
11
10
9
8
7
6
5
4
3
2
1
33pF
33pF
UART_RTS
PIO_7
PIO_8
PIO_14
PIO_13
PIO_12
PIO_11
PIO_15
PIO_9
PIO_10
RESET
GND
VDD_PIO
VDD_MEM
VREGIN_L
UART_TX
UART_RX
R646
C710
2.2uF
UART_CTS
C711
2.2uF
C618
C619
BT_CLK
BT_MUTE
2
R604
D604
MVS0603M04
0R
61
C620
680pF
62
1
470R
C700
2.2uF
R701
R700
CN604
C701
100nF
64
USB_DN
PIO_6
19
63
USB_DP
PIO_5
20
60
VDD_ANA
PCM_CLK
23
AIO_0
PCM_IN
22
D603
MVS0603M04
ANT
U700
C709
10pF
BT MODULE
NF2301
PCM_OUT
24
GND
PIO_4
21
R603
1K
PCM_SYNC
25
C633
1nF
56
BT-3V3
750R
R605
1K
R606
1K
SPK_L_P
SPK_R_N
SPK_R_P
SPK_L_N
VREGEN_H
VREGOUT_H
LX
GND
VDD_CHR
VDD_BAT
GND
MIC_BAIS
MIC_R_P
MIC_R_N
MIC_L_P
MIC_L_N
AGND
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
10nF
470nF
C638
470nF
C637
10nF
C636
C635
VDD_AUDIO
C634
2.2uF
51
R647
58
GND
59
AIO_1
57
ANT
SPI_MOSI
26
GND
SPI_CLK
27
55
GND
SPI_CSB
28
54
PIO_0
SPI_MISO
29
R607
53
PIO_2
LED0
30
BT_3V3
C706
2.2uF
BT_1V8
MICL+ [2]
MICL_ [2]
SPKR- [2]
SPKR+ [2]
SPKL- [2]
SPKL+ [2]
MICL_ [2]
MICL+ [2]
C707
2.2uF
V_OUT2
GND
V_OUT1
CAM_IN
GND
R_AV IN
CN201
6
5
4
3
2
1
[2] SPKL+
[2] SPKR+
0R
NC
0R
R705
R704
SPKL
SPKR[2]
0R
R708
R706
NC
R709
NC
0R
NC
33pF
C251
R710
R711
33pF
C250
R707
C708
100nF SPKR
SPKL[2]
D204
MVS0603M04
3V3
BT_3V3
A-a A-b
BT_GND
52
PIO_1
LED1
31
PIO_3
VREGIN_H
32
A 1/2
33pF
C252
D9V
33pF
C253
1812
FU201
FAV_CVBS [1]
J3
4
[2]SPI_MOSI
3
J4
DVH-840AVBT/XEUW5
[2]SPI_MISO
2
J5
F
[2]SPI_CSB
J24
1
J25
44
J26
E
J6
A-a 2/2
1
2
DVD_CVBS
C254
D9V
51R
R211
R210
LINE/SUB_R [2]
1 VIN1
8 VIN2
R312
27K
2.2uF/50V
C308
VOUT1
VOUT2
C307
1.5nF
C311
100nF
3
4
5
7
V+ VSAG2
6
IN2
100nF
C213
22uF/16V
100uF/16V
5
6
MCU39
MCU80
100nF
C214
IN3
GND
C212
100uF/16V
C211
8
VCC 7
[1]
C
10
R215
R218
R214
R213
[1]
A 1/2
CTLB
C210
22uF/16V
4
3
2 CTLA
VOUT
U202
BA7613F
1 IN1
C215
10uF
U201
NJM2267M
10uF
10uF
R202
120R
C202
GND VSAG1
2
C309
2.2uF/50V
C310
100uF/16V
R319
100R
C209
10uF
C208
10uF
C207
C201
R205
120R
R201
51R
C206
100nF
D201
MVS0603M04
33pF
C205
47uF/16V
LINE/SUB_L [2]
47R
ZD201
6V8
R212
100R
ZD202
3V3
CN202
0R
ZD203
3V3
V_OUT
[2]
V_IN
[2]
L201
10UH
C257
33pF
>
1.1 A
R203
R204
A-b 2/2
3
[2]SPI_CLK
D
J28
C
R317 39K
B
D203
MVS0603M04
A
2
R318 33K
1
4
2.2uF
DVD_POWER
SPKL+ [2]
SPKL- [2]
SPKR- [2]
SPKR+ [2]
C716
C718
22uF/16V
L700
10UH
2.2uF R715
C715
R714
2.2uF
2.2uF
2.2uF R713
C713
C714
2.2uF R712
R703
0R
PIO_6
[2]
19
5.6K
5.6K
5.6K
5.6K
22K
C719
100nF
C720
100uF/16V
R716
PIO_4
21
22K
PIO_5
20
R717
SPI_MISO [2]
SPI_CSB [2]
SPI_CLK [2]
SPI_MOSI [2]
PORT4
PIO_7
PCM_OUT
PCM_CLK
23
22K
VCC 10
VO1 1
PCM_IN
22
C721
2.2uF
3
U703
1117V33
R719
22K
C722
1uF
2.2uF 15K R733
C731
PORT4
[2]
C732
2.2uF
2.2uF 15K R732
C717
2.2uF
BT-3V3
C705
100nF
VREGEN_H
VREGOUT_H
LX
GND
VDD_CHR
C730
R731
10R
BT_3V3
BT_3V3
GND 5
U701
TPA6112A2
8 IN2-
4 BYPASS
VO2 9
7 IN2+ SHUTDOWN 6
2 IN1_3 IN1+
R718
24
PIO_8
C712
R702
0R
18
PCM_SYNC
25
17
26
PIO_14
SPI_CLK
27
16
SPI_CSB
28
BT_CE
SPI_MISO
29
PIO_13
LED0
30
PIO_12
LED1
31
15
33
34
35
36
37
DVH-840AVBT/XEUW5
7
R958
R957
BT_AL [2]
BT_AR [2]
7.5K
1nF
R962
C950
10K
R964
4.7K
22K
R963
22K
R966
R965
1nF
C949
4.7K
R961
10K
[2]SPI_CLK
AUX-R [2]
AUX-R [2]
AUX-L [2]
DVD_R [2]
DVD_L [2]
C932
C938
22uF/16V
C937
2.2uF/16V
2.2uF/50V
C936
C931
2.2uF/16V
2.2uF/16V
C309
2.2uF/50V
27K
28
SE1L
SE2R
14
CREF
13 DIFFR
12 DIFFG
11 DIFFL
10 SE1R
9
8
7
U904
TDA7419
16
GND 15
OUTSWL
OUTRF 17
OUTRR 18
OUTLR 19
OUTLF 20
MUTE 21
SCL 22
23
SE3R
SE2L
VDD 24
SDA
SE3L
SAIN 25
SAOUT 26
VREF 27
OUTSWR
6
ACOUTL
R317 39K
33pF
33pF
C961
R969
R968
R967
LINE/SUB_
D5V
C9
100
10
[2] LINE/SUB_
22uF/16V
A-b 2/2
GND
4.7K
1K
1K
100uF/16V
C943
C941
C962
R318 33K
C303
100uF/16V
LINE OUT CIRCUITRY
C301
2.2uF/50V
2.2uF/50V
C302
C307
1.5nF
5
4
ACINL
ACINR
2
3
ACOUTR
27K
27K
1
R301
R302
R315
27K
2.2uF/50V
C308
R312
2.2uF
2.2uF
C935
TUN_R [1]
TUN_L [1]
C934
2.2uF
2.2uF
C933
C940
2.2uF/16V
A 1/2
BT_AR [2]
BT_AL [2]
AUX-L [2]
DVD_L [2]
[2]SPI_CSB
DVD_R [2]
C939
LF [2]
RF [2]
LINE/SUB_R [2]
LINE/SUB_L [2]
7
A-a A-b
F_AUX_R [1]
15K
15K
BT_3V3
C706
2.2uF
BT_1V8
6
F_AUX_L [1]
A 1/2
CDP_R [1]
CDP_L [1]
1nF
R734
SPI_MOSI
2
VREGIN_H
32
7.5K
C733
14
7.5K
R735
SDI
1nF
C734
GND 11
1
[2]SPI_MOSI
100pF
SDO
7.5K
R959
BT_3V3
100pF
C959
6
R960
C306
100uF/16V
20
L-CIN
L-GND
1
RL-OUT 19
L-CONT
2
RL-FB 18
FL-OUT
3
17
R313
16
RL-IN
FL-FB
4
V+
14
RR-FB
15
6
FL-IN
5
39K
RR-IN
REF
13
RR-OUT
FR-IN
7
FR-FB
8
33K
R314
5
C960
5
8
A-a 2/2
8
45
A
B
C
D
E
F
[2]SPI_MISO
1
2
3
4
10.3 SB SMT UNIT (POWER PART) (GUIDE PAGE)
A
B-a 1/2
B
C
D
E
F
B 1/2
46
DVH-840AVBT/XEUW5
1
2
3
4
5
6
7
8
A
B-b 1/2
B
C
D
E
F
B 1/2
DVH-840AVBT/XEUW5
5
6
7
8
47
F
48
NM
B-b 1/2
S24C16CIJ8T1
B-a B-b
B
B 2/2
SMT UNIT
B 1/2 SB
(POWER PART)
1
1
2
A
C
D
E
2
DVH-840AVBT/XEUW5
3
4
3
4
B-b 1/2
U7
341S2162-TBB (iPod_2.0B)
5
6
6
DVH-840AVBT/XEUW5
B-a B-b
B 2/2
B 2/2
5
7
7
8
A
B
C
D
E
8
49
F
B-a 1/2
50
B 2/2
B 2/2
B
C
D
E
F
B 2/2
NM
B-b 1/2
2
1
2
CON201
A 1/2
B-a B-b
A
1
DVH-840AVBT/XEUW5
3
4
3
4
6
7
8
A
B 2/2
B 2/2
B-b 1/2
5
B
B-a B-b
C
B 2/2
B 2/2
B 2/2
D
E
F
DVH-840AVBT/XEUW5
5
6
B-a 1/2
7
8
51
1
2
3
4
3
4
10.4 SB SMT UNIT (MAIN PART) (GUIDE PAGE)
A
B-a 2/2
B
C
D
E
F
B 2/2
52
DVH-840AVBT/XEUW5
1
2
5
6
7
8
A
B-b 2/2
B
C
D
E
F
B 2/2
DVH-840AVBT/XEUW5
5
6
7
8
53
F
54
B 1/2
B-b 2/2
D
ZR36966ELCG-H
B-a B-b
1
B 1/2
B 1/2
SMT UNIT
B 2/2 SB
(MAIN PART)
1
2
2
3
3
4
A
B
C
E
DVH-840AVBT/XEUW5
4
B-b 2/2
B 1/2
5
B-a B-b
B 1/2
B 1/2
B 1/2
B 1/2
5
6
6
7
DVH-840AVBT/XEUW5
7
8
A
B
C
D
E
8
55
F
2
1
2
3
4
B 1/2
B-b 2/2
A
1
64Mbit: M12L64164A-7TG
B
B-a B-b
C
D
E
F
B-a 2/2
56
DVH-840AVBT/XEUW5
3
4
6
7
8
B-b 2/2
5
A
B
B-a B-b
B 1/2
C
D5869S
D
B 1/2
E
F
DVH-840AVBT/XEUW5
5
6
B-a 2/2
7
8
57
1
2
3
4
3
4
10.5 KB PCB and AUX PCB (GUIDE PAGE)
A
C-a
B
C
D
E
F
C
58
DVH-840AVBT/XEUW5
1
2
5
6
7
8
A
C-b
B
C
D
E
F
C D
DVH-840AVBT/XEUW5
5
6
7
8
59
1
2
3
4
3
4
C
KB PCB
A
B
C-a C-b
C
D
F
C-b
E
60
DVH-840AVBT/XEUW5
1
2
5
BSM
6
DVH-840AVBT/XEUW5
7
C-a C-b
D
KB ASSY
Consists of
KB PCB
AUX PCB
C
AP34063
AUX PCB
6
7
C-b D
LEFT
NJM3414AM
5
8
A
B
C
D
E
8
61
F
2
1
2
3
4
3
4
C-b
A
1
B
C-a C-b
D
C
IRM6640M2F78
D
E
F
C-a
62
DVH-840AVBT/XEUW5
5
CON1
E
NM
MULTICONTROL
C-a C-b
POWER/MUTE
D
AP5727
UP
DVH-840AVBT/XEUW5
6
7
C-b
LEF
6
DOWN
RIGHT
5
7
8
C-a
8
63
A
B
C
D
E
F
1
2
3
4
10.6 CB PCB and LB PCB
E
A
CB PCB
B
C
A 1/2
C
CN402
CON201
D
F
E
LB PCB
EJECT
A 1/2
CON406
RESET
CB/LB ASSY
Consists of
CB PCB
LB PCB
F
E F
64
DVH-840AVBT/XEUW5
1
2
3
4
5
6
7
8
A
B
C
D
E
F
DVH-840AVBT/XEUW5
5
6
7
8
65
1
2
3
4
11. PCB CONNECTION DIAGRAM
11.1 MB UNIT
A
NOTE FOR PCB DIAGRAMS
1.The parts mounted on this PCB
include all necessary parts for
several destination.
For further information for
respective destinations, be sure
to check with the schematic diagram.
2.Viewpoint of PCB diagrams
A
MB UNIT
POWER SUPPLY
Capacitor
Connector
SIDE A
B
Chip Part
P.C.Board
SIDE B
C
SERVO
D
E
F
F
A
66
CN406
FRONT
DVH-840AVBT/XEUW5
1
2
3
4
5
6
7
8
A
SIDE A
ANTENNA
B
C
B
CN6
WIRE
REMOTE
CON201
D
E
E
CON2
F
A
FRONT
DVH-840AVBT/XEUW5
5
6
7
8
67
1
A
A
2
3
4
3
4
MB UNIT
B
C
D
E
F
A
68
DVH-840AVBT/XEUW5
1
2
5
6
7
8
A
SIDE B
B
C
D
E
100
0.5W
100
0.5W
F
A
DVH-840AVBT/XEUW5
5
6
7
8
69
1
2
3
4
11.2 SB SMT UNIT
B
SB SMT UNIT
SIDE A
A
B
C
D
E
F
A
CON201
B
70
DVH-840AVBT/XEUW5
1
2
3
4
5
B
6
7
8
SB SMT UNIT
SIDE B
A
B
C
D
E
F
B
DVH-840AVBT/XEUW5
5
6
7
8
71
LEFT
POWER/MUTE
SRC
BAND
A
UP
B
OK
ESC
RIGHT
BSM
USB BUS
4
3
2
1
DVH-840AVBT/XEUW5
72
MULTI-CONTROL
DOWN
D
F
SIDE A
KB PCB
C
4
3
2
1
11.3 KB PCB
C
D
E
C
5
C
6
7
8
KB PCB
SIDE B
A
B
C
D
E
E
CON1
F
C
DVH-840AVBT/XEUW5
5
6
7
8
73
1
2
3
4
11.4 AUX PCB
D
AUX PCB
D
AUX PCB
SIDE A
A
B
C
SIDE B
C
D
E
F
D
74
DVH-840AVBT/XEUW5
1
2
3
4
5
6
7
8
11.5 CB PCB
E
CB PCB
SIDE A
A
C
CON201
B
C
E
CB PCB
SIDE B
A
CN402
D
E
F
E
DVH-840AVBT/XEUW5
5
6
7
8
75
1
2
3
4
11.6 LB PCB
F
LB PCB
SIDE A
EJECT
A
B
A
RESET
CON406
DTHSW
C
F
LB PCB
SIDE B
D
E
F
F
76
DVH-840AVBT/XEUW5
1
2
3
4
5
6
7
8
12. ELECTRICAL PARTS LIST
NOTE:
Parts whose parts numbers are omitted are subject to being not supplied.
The part numbers shown below indicate chip components.
Chip Resistor
RS1/_S___J,RS1/__S___J
Chip Capacitor (except for CQS.....)
CKS....., CCS....., CSZS.....
The > mark found on some component parts indicates the importance of the safety factor of the part.
Therefore, when replacing, be sure to use parts of identical designation.
Meaning of the figures and others in the parentheses in the parts list.
Example) IC 301 is on the point (face A, 91 of x-axis, and 111 of y-axis) of the corresponding
PC board.
IC 301 (A, 91, 111) IC NJM2068V
The expression of the unit in this manual is shown by u instead of . Please do not make a mistake.
Circuit Symbol and No.
Circuit Symbol and No.
Part No.
A:DVH-840AVBT/XEUW5
B:DVH-8480AVBT/XFBR
Unit Number : 843DM7376HRMB003-FY(A)
: CYW1008(B)
Unit Name : MB Unit
Unit Number : 842DM7376HRSB003-FY(A)
: 882DM7376HBSB003-FY(B)
Unit Name : SB SMT Unit
Unit Number :
Unit Name : KB Assy
Unit Number :
Unit Name : CB/LB Assy
A
Unit Number : 843DM7376HRMB003-FY(A)
: CYW1008(B)
: MB Unit
Unit Name
MISCELLANEOUS
IC
IC
142400001288-FY
142400001362-FY
U809
U903
U904
Q201
Q202
IC
IC
IC
TRANSISTOR
TRANSISTOR
142400001407-FY
PAL007E
142400000384-FY
142245000077-FY
142245000029-FY
Q203
Q204
Q205
Q206
Q303
TRANSISTOR
TRANSISTOR
TRANSISTOR
FET
TRANSISTOR
142245000029-FY
142245000077-FY
142245000077-FY
142266000069-FY
142245000017-FY
Q304
Q306
Q307
Q308
Q309
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
142245000048-FY
142245000021-FY
142245000021-FY
142245000021-FY
142245000021-FY
Q310
Q311
Q401
Q402
Q403
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
MOSFET
142245000021-FY
142245000021-FY
142245000017-FY
142245000077-FY
142266000075-FY
Q406
Q408
Q409
Q410
Q411
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
142245000017-FY
142245000017-FY
142290000144-FY
142245000077-FY
142245000017-FY
IC
IC
IC
IC
IC
142400001072-FY
142490000340-FY
142400000276-FY
142400000817-FY
142400001137-FY
Q412
Q413
Q414
Q415
Q418
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
142290000144-FY
142245000017-FY
142290000144-FY
142245000017-FY
142245000048-FY
U401
U402
U403
U501
U700
IC
IC
IC
IC
MODULE
142400001175-FY
142400000218-FY
142400001362-FY
142490000375-FY
144830000304-FY
Q502
Q503
Q801
Q802
Q804
TRANSISTOR
TRANSISTOR
FET
TRANSISTOR
TRANSISTOR
142290000144-FY
142290000144-FY
142266000069-FY
142245000077-FY
142245000077-FY
U701
U703
U802
IC
IC
IC
142410000667-FY
142400001048-FY
142400001288-FY
Q810
Q813
Q907
TRANSISTOR
TRANSISTOR
TRANSISTOR
142245000077-FY
142254000018-FY
142290000144-FY
DVH-840AVBT/XEUW5
6
7
B
Part No.
U803
U804
U101
U103
U201
U202
U301
5
A
8
C
D
E
F
77
1
Circuit Symbol and No.
A
B
C
D
E
F
2
3
Part No.
D101
D102
SW DIODE
SW DIODE
142200000019-FY
142200000019-FY
D103
D201
D203
D204
D205
ESD DIODE
ESD DIODE
ESD DIODE
ESD DIODE
ESD DIODE
142239000012-FY
142236000006-FY
142236000006-FY
142236000006-FY
142236000006-FY
D303
D310
D400
D405
D406
SW DIODE
SW DIODE
ESD DIODE
REC DIODE
REC DIODE
D413
D417
D418
D419
D430
4
Circuit Symbol and No.
> FU201
> FU901
Part No.
FUSE 1.1A
FUSE 1.1A
144800000049-FY
144800000049-FY
X101
X401
X402
ZD201
ZD202
TCXO 4.0MHz
TCXO 32.768KHz
TCXO 8MHz
ZENER DIODE
ZENER DIODE
142825000256-FY
122820000014-FY
142825000055-FY
142224000025-FY
142224000010-FY
142200000019-FY
142200000019-FY
142236000006-FY
142206000003-FY
142206000003-FY
ZD203
ZD205
ZD402
ZD501
ZD502
ZENER DIODE
ZENER DIODE
ZENER DIODE
ZENER DIODE
ZENER DIODE
142224000010-FY
142224000023-FY
142224000025-FY
142224000025-FY
142224000010-FY
SW DIODE
ESD DIODE
SW DIODE
SW DIODE
ESD DIODE
142200000019-FY
142236000006-FY
142200000019-FY
142200000019-FY
142236000006-FY
ZD503
ZD804
CN201
CN202
CN402
ZENER DIODE
IC
I/O
SOCKET
FPC SOCKET
142224000018-FY
142400000895-FY
123830001333-FY
123805000145-FY
143815000208-FY
D431
D432
D433
D434
D435
ESD DIODE
ESD DIODE
ESD DIODE
ESD DIODE
ESD DIODE
142236000006-FY
142236000006-FY
142236000006-FY
142236000006-FY
142236000006-FY
CN901
CON201
CON406
SOCKET
FPC SOCKET
FPC SOCKET
123830010086-FY
143800000019-FY
123800010040-FY
D436
D437
D438
D439
D440
ESD DIODE
ESD DIODE
ESD DIODE
ESD DIODE
ESD DIODE
142236000006-FY
142236000006-FY
142236000006-FY
142236000006-FY
142236000006-FY
R10
R101
R102
R103
R104
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/8SQ101J
RS1/10SR102J
RS1/10SR102J
RS1/10SR101J
RS1/10SR330J
D444
D445
D502
D503
D504
ESD DIODE
ESD DIODE
SW DIODE
SW DIODE
SW DIODE
142236000006-FY
142236000006-FY
142200000019-FY
142200000019-FY
142200000019-FY
R105
R106
R107
R108
R117
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/10SR472J
RS1/10SR472J
RS1/10SR223J
RS1/10SR223J
RS1/8SQ2R2J
D505
D506
D507
D508
D510
SW DIODE
ESD DIODE
ESD DIODE
ESD DIODE
ESD DIODE
142200000019-FY
142239000012-FY
142239000012-FY
142236000006-FY
142236000006-FY
R127
R128
R129
R130
R131
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/10SR474J
RS1/10SR474J
RS1/10SR472J
RS1/10SR102J
RS1/10SR102J
D511
D555
D603
D604
D801
ESD DIODE
ESD DIODE
ESD DIODE
ESD DIODE
REC DIODE
142236000006-FY
142236000006-FY
142236000006-FY
142236000006-FY
142206000003-FY
R201
R202
R204
R205
R206
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/10SR510J
RS1/10SR121J
RS1/4SA0R0J
RS1/10SR121J
RS1/8SQ101J
D802
D803
D806
D901
D902
REC DIODE
SCHOTTKY DIODE
SCHOTTKY DIODE
REC DIODE
TVS DIODE
142206000003-FY
142233000074-FY
142233000074-FY
122206000006-FY
142239000008-FY
R210
R211
R212
R213
R215
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/10SR470J
RS1/10SR510J
RS1/8SQ101J
RS1/10SR750J
RS1/10SR750J
L102
L103
L104
L105
L106
INDUCTOR
INDUCTOR
AXIS INDUCTOR
AXIS INDUCTOR
INDUCTOR
122000000300-FY
142000000296-FY
142010000014-FY
142010000014-FY
142000000298-FY
R219
R220
R250
R251
R270
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/8SQ0R0J
RS1/8SQ0R0J
RS1/8SQ102J
RS1/10SR472J
RS1/10SR472J
L108
L201
L401
L700
L801
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
AXIS INDUCTOR
142000000028-FY
142000000028-FY
142000000028-FY
142000000028-FY
142005000002-FY
R271
R272
R273
R274
R301
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/10SR473J
RS1/10SR473J
RS1/8SQ102J
RS1/10SR102J
RS1/10SR273J
L803
L819
L824
AXIS INDUCTOR
AXIS INDUCTOR
AXIS INDUCTOR
142005000002-FY
142005000002-FY
142005000002-FY
R302
R313
RESISTOR
RESISTOR
RS1/10SR273J
RS1/10SR393J
78
RESISTORS
DVH-840AVBT/XEUW5
1
2
3
4
5
Circuit Symbol and No.
6
7
Part No.
Circuit Symbol and No.
8
Part No.
R314
R315
R316
RESISTOR
RESISTOR
RESISTOR
RS1/10SR393J
RS1/10SR273J
RS1/10SR273J
R450
R451
R452
RESISTOR
RESISTOR
RESISTOR
RS1/10SR473J
RS1/8SQ102J
RS1/10SR473J
R317
R318
R319
R320
R321
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/10SR393J
RS1/10SR393J
RS1/4SA100J
RS1/10SR101J
RS1/10SR391J
R453
R454
R455
R457
R458
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/10SR473J
RS1/10SR473J
RS1/10SR473J
RS1/10SR103J
RS1/10SR101J
R322
R323
R324
R325
R326
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/10SR104J
RS1/10SR103J
RS1/10SR471J
RS1/10SR101J
RS1/10SR223J
R459
R460
R460A
R460B
R461
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/10SR433J
RS1/8SQ100J
141614000101-FY
141614000101-FY
141614000102-FY
R327
R328
R329
R330
R331
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/10SR223J
RS1/10SR471J
RS1/10SR101J
RS1/10SR471J
RS1/10SR223J
R462
R463
R464
R465
R466
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/10SR562J
RS1/10SR103J
RS1/10SR104J
RS1/10SR562J
RS1/10SR223J
R340
R341
R342
R343
R401
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/10SR101J
RS1/10SR223J
RS1/10SR471J
RS1/10SR101J
RS1/10SR0R0J
R467
R468
R473
R474
R475
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/10SR561J
RS1/10SR0R0J
RS1/10SR103J
RS1/10SR473J
RS1/10SR102J
R402
R403
R404
R405
R406
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/10SR473J
RS1/10SR101J
RS1/10SR101J
RS1/10SR101J
RS1/10SR101J
R476
R477
R480
R482
R483
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/10SR103J
RS1/10SR684J
RS1/10SR102J
RS1/10SR102J
RS1/10SR102J
R407
R408
R409
R411
R412
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/10SR101J
RS1/10SR102J
RS1/10SR101J
RS1/10SR104J
RS1/10SR561J
R485
R486
R487
R489
R490
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/8SQ102J
RS1/10SR103J
RS1/4SA100J
RS1/8SQ102J
RS1/10SR102J
R413
R414
R415
R417
R418
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/10SR473J
RS1/10SR103J
RS1/10SR103J
RS1/10SR101J
RS1/10SR105J
R491
R492
R494
R495
R496
RESISTOR
RESISTOR
CHIP BEAD
RESISTOR
RESISTOR
RS1/10SR103J
RS1/10SR102J
142040000054-FY
RS1/10SR103J
RS1/10SR103J
R419
R420
R422
R423
R424
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/10SR562J
RS1/10SR562J
RS1/10SR102J
RS1/10SR102J
RS1/10SR473J
R497
R498
R499
R502
R503
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/10SR103J
RS1/10SR103J
RS1/10SR222J
RS1/10SR101J
RS1/4SA102J
R425
R426
R427
R428
R429
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/10SR473J
RS1/10SR473J
RS1/10SR101J
RS1/10SR473J
RS1/10SR103J
R504
R508
R509
R510
R511
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/10SR473J
RS1/10SR473J
RS1/10SR102J
RS1/10SR473J
RS1/10SR224J
R430
R431
R432
R433
R434
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/10SR102J
RS1/10SR102J
RS1/10SR102J
RS1/10SR102
RS1/10SR102J
R512
R513
R514
R515
R516
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/10SR223J
RS1/10SR103J
RS1/10SR123J
RS1/10SR223J
RS1/10SR473J
R435
R437
R438
R439
R440
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/10SR101J
RS1/10SR102J
RS1/10SR102J
RS1/10SR102J
RS1/10SR473J
R517
R518
R519
R520
R521
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/10SR105J
RS1/10SR473J
RS1/10SR103J
RS1/10SR103J
RS1/10SR622J
R442
R443
RESISTOR
RESISTOR
RS1/10SR103J
RS1/10SR103J
R522
R523
RESISTOR
RESISTOR
RS1/10SR752J
RS1/10SR104J
DVH-840AVBT/XEUW5
5
6
7
8
A
B
C
D
E
F
79
1
Circuit Symbol and No.
A
B
C
D
E
F
2
3
Part No.
R524
R525
R526
RESISTOR
RESISTOR
RESISTOR
RS1/10SR103J
RS1/10SR103J
RS1/10SR473J
R530
R532
R603
R604
R605
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/10SR223J
RS1/10SR101J
RS1/10SR102J
RS1/10SR0R0J
RS1/10SR102J
R606
R607
R700
R701
R702
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/10SR102J
RS1/10SR751J
RS1/10SR331J
RS1/10SR331J
RS1/10SR0R0J
R703
R704
R706
R708
R710
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/10SR0R0J
RS1/10SR0R0J
RS1/10SR0R0J
RS1/10SR0R0J
RS1/10SR0R0J
R712
R713
R714
R715
R716
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/10SR562J
RS1/10SR562J
RS1/10SR562J
RS1/10SR562J
RS1/10SR223J
R717
R718
R719
R720
R731
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/10SR223J
RS1/10SR223J
RS1/10SR223J
RS1/10SR223J
RS1/10SR100J
R732
R733
R734
R735
R801
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/10SR153J
RS1/10SR153J
RS1/10SR752J
RS1/10SR752J
RS1/8SQ102J
R802
R804A
R804B
R806
R807
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/10SR472J
141614000022-FY
141614000022-FY
RS1/10SR393J
RS1/10SR153J
R814
R814A
R819
R820
R824
RCF
RESISTOR
RESISTOR
RESISTOR
RESISTOR
141648000022-FY
RS1/4SA0R0J
RS1/10SR473J
RS1/8SQ101J
RS1/10SR473J
R825
R826
R827
R830
R831
R841
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/10SR272J
RS1/10SR621J
RS1/10SR822J
RS1/10SR822J
RS1/8SQ0R0J
RS1/10SR201J
R842
R860
R861
R863
R881
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/10SR272J
RS1/10SR103J
RS1/10SR103J
RS1/4SA471J
RS1/10SR303J
R882
R883
R884
R886
R887
R936
R937
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/10SR472J
RS1/10SR103J
RS1/10SR103J
141614000101-FY
141614000101-FY
RS1/10SR473
RS1/10SR103J
80
4
Circuit Symbol and No.
Part No.
R938
R939
R940
R941
R942
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/10SR822J
RS1/10SR822J
RS1/10SR822J
RS1/10SR822J
RS1/10SR474J
R943
R945
R946
R947
R948
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/10SR474J
RS1/10SR474J
RS1/10SR474J
RS1/10SR223J
RS1/10SR223J
R949
R950
R951
R952
R954
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/10SR223J
RS1/10SR223J
RS1/10SR752J
RS1/10SR103J
RS1/10SR473J
R956
R957
R958
R959
R960
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/10SR103J
RS1/10SR153J
RS1/10SR153J
RS1/10SR752J
RS1/10SR752J
R961
R962
R963
R964
R965
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/10SR103J
RS1/10SR103J
RS1/10SR223J
RS1/10SR223J
RS1/10SR472J
R966
R967
R968
R969
R971
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/10SR472J
RS1/10SR102J
RS1/10SR102J
RS1/10SR472J
RS1/8SQ100J
CAPACITORS
C103
C104
C109
C110
C113
CAPACITOR
CAPACITOR
E.CAP
CAPACITOR
CAPACITOR
CKSRYB102K50
CKSRYB102K50
141830090107-FY
CKSRYB104K16
CCSRCH220J50
C114
C115
C116
C117
C118
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CCSRCH220J50
141803000225-FY
141803000225-FY
CKSRYB104K16
CKSRYB104K16
C119
C120
C121
C122
C123
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CKSRYB103K50
CKSRYB104K16
CKSRYB103K50
CKSRYB104K16
141803000474-FY
C124
C125
C126
C127
C128
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CKSRYB105K16
141803000474-FY
141803000474-FY
CCSRCH330J50
CCSRCH330J50
C129
C130
C140
C141
C142
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CKSRYB104K16
CKSRYB153K50
CKSRYB153K50
CKSRYB103K50
CKSRYB104K16
C143
C144
CAPACITOR
CAPACITOR
CKSRYB103K50
CCSRCH100D50
DVH-840AVBT/XEUW5
1
2
3
4
5
Circuit Symbol and No.
6
7
Part No.
Circuit Symbol and No.
8
Part No.
C145
C146
C201
CAPACITOR
CAPACITOR
CAPACITOR
CKSRYB103K50
CKSRYB103K50
141809010106-FY
C409
C410
C411
E.CAP
E.CAP
CAPACITOR
141830070107-FY
141830090107-FY
CKSRYB104K16
C202
C203
C204
C205
C206
CAPACITOR
CAPACITOR
E.CAP
E.CAP
CAPACITOR
141809010106-FY
CKSRYB104K16
141830090107-FY
141830110476-FY
CKSRYB104K16
C412
C413
C414
C415
C416
E.CAP
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
141830090107-FY
CKSRYB104K16
CKSQYB225K16
CKSRYB104K16
CKSRYB104K16
C207
C208
C209
C210
C211
CAPACITOR
CAPACITOR
CAPACITOR
E.CAP
E.CAP
141809010106-FY
141809010106-FY
141809010106-FY
141830090226-FY
141830090107-FY
C417
C419
C420
C450
C451
E.CAP
CAPACITOR
CAPACITOR
CAPACITOR
E.CAP
141830050225-FY
CKSQYB225K16
141890002209-FY
CKSRYB102K50
141830090107-FY
C212
C213
C214
C215
C249
CAPACITOR
CAPACITOR
E.CAP
E.CAP
CAPACITOR
CKSRYB104K16
CKSRYB104K16
141830090107-FY
141830090226-FY
CKSRYB104K16
C473
C474
C475
C476
C477
E.CAP
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
141830090226-FY
CKSRYB104K16
CKSRYB104K16
CCSRCH330J50
CCSRCH330J50
C250
C251
C252
C253
C254
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CCSRCH330J50
CCSRCH330J50
CCSRCH330J50
CCSRCH330J50
CCSRCH330J50
C501
C502
C503
C504
C505
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CKSRYB104K16
141803000225-FY
CKSRYB104K16
CCSRCH330J50
CCSRCH330J50
C255
C256
C301
C302
C303
CAPACITOR
CAPACITOR
E.CAP
E.CAP
E.CAP
CCSRCH330J50
CCSRCH330J50
141830050225-FY
141830050225-FY
141830090107-FY
C511
C520
C618
C619
C620
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CKSRYB104K16
CKSRYB104K16
CCSRCH330J50
CCSRCH330J50
CKSRYB681K50
C305
C306
C307
C308
C309
E.CAP
E.CAP
CAPACITOR
E.CAP
E.CAP
141830090107-FY
141830090107-FY
CKSRYB152K50
141830050225-FY
141830050225-FY
C633
C634
C635
C636
C637
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CKSRYB102K50
CKSQYB225K16
CKSRYB103K50
141803000474-FY
141803000474-FY
C310
C311
C312
C313
C314
E.CAP
CAPACITOR
CAPACITOR
E.CAP
E.CAP
141830090107-FY
CKSRYB104K16
CKSRYB152K50
141830090107-FY
141830050225-FY
C638
C700
C701
C702
C703
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CKSRYB103K50
141803000225-FY
CKSRYB104K16
141806020106-FY
141803000225-FY
C315
C316
C317
C320
C321
E.CAP
E.CAP
E.CAP
CAPACITOR
CAPACITOR
141830050225-FY
141830090226-FY
141830090226-FY
CCSRCH330J50
CCSRCH330J50
C704
C705
C706
C707
C708
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
141803000225-FY
CKSRYB104K16
141803000225-FY
141806020106-FY
CKSRYB104K16
C322
C323
C324
C325
C326
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CCSRCH330J50
CKSRYB104K16
CKSRYB104K16
CCSRCH330J50
CCSRCH330J50
C709
C711
C712
C713
C714
RESISTOR
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
RS1/10SR0R0J
141806020106-FY
141803000225-FY
141803000225-FY
141803000225-FY
C327
C328
C329
C400
C401
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CCSRCH330J50
CCSRCH330J5
CCSRCH330J50
CKSRYB102K50
CCSRCH120J50
C715
C716
C717
C718
C719
CAPACITOR
CAPACITOR
CAPACITOR
E.CAP
CAPACITOR
141803000225-FY
141803000225-FY
141806020106-FY
141830090226-FY
CKSRYB104K16
C402
C403
C404
C405
C406
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CCSRCH120J50
CCSRCH220J50
CCSRCH220J50
CKSRYB104K16
CKSRYB104K16
C720
C721
C722
C730
C731
E.CAP
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
141830090107-FY
141806020106-FY
CKSRYB105K16
141803000225-FY
141803000225-FY
C407
C408
CAPACITOR
CAPACITOR
CKSRYB104K16
CKSRYB102K50
C732
C733
CAPACITOR
CAPACITOR
CKSQYB225K16
CKSRYB102K50
DVH-840AVBT/XEUW5
5
6
7
8
A
B
C
D
E
F
81
1
Circuit Symbol and No.
A
B
C
D
E
F
2
3
Part No.
4
Circuit Symbol and No.
Part No.
C734
C803
C804
CAPACITOR
E.CAP
E.CAP
CKSRYB102K50
141830090226-FY
141830090107-FY
C948
C949
C950
CAPACITOR
CAPACITOR
CAPACITOR
141803000474-FY
CKSRYB102K50
CKSRYB102K50
C805
C806
C810
C811
C812
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
E.CAP
CKSRYB104K16
CKSRYB103K50
CKSRYB104K16
CKSRYB104K16
141830090107-FY
C959
C960
C961
C962
C963
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CCSRCH101J50
CCSRCH101J50
CCSRCH330J50
CCSRCH330J50
CCSRCH330J50
C814
C815
C816
C817
C818
CAPACITOR
CAPACITOR
E.CAP
CAPACITOR
E.CAP
141809010106-FY
CKSRYB104K16
141830070107-FY
CKSRYB104K16
141842030108-FY
C964
C965
C966
C967
C968
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CCSRCH330J50
CCSRCH330J50
CCSRCH330J50
CCSRCH330J50
CCSRCH330J50
C819
C822
C854
C855
C856
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
E.CAP
CKSRYB104K16
CKSRYB104K16
141809010106-FY
CKSRYB104K16
141830070107-FY
C969
C970
C971
C972
C973
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CKSRYB104K16
CCSRCH330J50
CCSRCH330J50
CCSRCH330J50
CCSRCH330J50
C857
C858
C859
C860
C861
CAPACITOR
E.CAP
CAPACITOR
E.CAP
CAPACITOR
CKSRYB104K16
141842030108-FY
CKSRYB104K16
141830090226-FY
CKSRYB104K16
C974
C975
C976
C977
C978
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CCSRCH330J50
CCSRCH330J50
CCSRCH330J50
CCSRCH330J50
CCSRCH330J50
C862
C863
C863A
C881
C882
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
E.CAP
CKSRYB104K16
141809010106-FY
141809010106-FY
CCSRCH101J50
141830090107-FY
C979
C980
C981
C982
C983
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CCSRCH330J50
CCSRCH330J50
CCSRCH330J50
CCSRCH330J50
CCSRCH330J50
C917
C918
C919
C919A
C920
CAPACITOR
E.CAP
CAPACITOR
CAPACITOR
CAPACITOR
CKSRYB105K16
141830110476-FY
141803000225-FY
141803000225-FY
CKSRYB104K16
C984
C985
C986
CAPACITOR
CAPACITOR
CAPACITOR
CCSRCH330J50
CCSRCH330J50
CCSRCH330J50
C921
C922
C923
C923A
C924
E.CAP
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
141842080338-FY
CKSRYB104K16
CKSQYB105K25
CKSQYB105K25
CKSQYB105K25
C924A
C925
C925A
C926
C926A
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CKSQYB105K25
CKSQYB105K25
CKSQYB105K25
CKSQYB105K25
CKSQYB105K25
C931
C932
C933
C934
C935
E.CAP
E.CAP
CAPACITOR
CAPACITOR
E.CAP
141830050225-FY
141830050225-FY
141803000225-FY
141803000225-FY
141830050225-FY
C936
C937
C938
C939
C940
E.CAP
E.CAP
E.CAP
CAPACITOR
CAPACITOR
141830050225-FY
141830050225-FY
141830090226-FY
CKSQYB225K16
CKSQYB225K16
C941
C942
C943
C944
C945
E.CAP
CAPACITOR
E.CAP
CAPACITOR
CAPACITOR
141830090226-FY
CKSRYB104K16
141830090107-FY
CKSQYB225K16
CKSQYB225K16
C946
C947
CAPACITOR
CAPACITOR
CKSQYB225K16
CKSQYB225K16
82
B
Unit Number : 842DM7376HRSB003-FY(A)
Unit Name
: 882DM7376HBSB003-FY(B)
: SB SMT Unit
MISCELLANEOUS
U2
U3
U4
U5
U6
IC
IC
IC
IC
IC
142410000759-FY
142400001042-FY
142410000532-FY
142410000636-FY
142400000819-FY
U7
U8
U9
U10
U11
IC
IC
IC
IC
IC
341S2162
142410000806-FY
142400000416-FY
142400001047-FY
142400001048-FY
Q1
Q2
Q3
Q4
Q5
TRANSISTOR
TRANSISTOR
FET
FET
FET
142251000005-FY
142251000005-FY
142266000069-FY
142266000002-FY
142266000002-FY
Q6
Q7
Q8
D1
D2
TRANSISTOR
TRANSISTOR
TRANSISTOR
SW DIODE
SW DIODE
142290000012-FY
142290000005-FY
142290000144-FY
142200000019-FY
142200000019-FY
DVH-840AVBT/XEUW5
1
2
3
4
5
Circuit Symbol and No.
6
7
Part No.
Circuit Symbol and No.
8
Part No.
D3
D4
D5
D6
D7
SW DIODE
SW DIODE
SW DIODE
REC DIODE
ZENER DIODE
142200000019-FY
142200000019-FY
142200000019-FY
142206000013-FY
142224000016-FY
R6
R7
R8
R9
R10
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/16SS222J
RS1/16SS103J
RS1/16SS103J
RS1/16SS103J
RS1/16SS103J
L1
L3
L4
L5
L6
CHIP BEAD
CHIP BEAD
CHIP BEAD
INDUCTOR
INDUCTOR
142040000012-FY
142040000012-FY
142040000012-FY
142000000333-FY
142000000333-FY
R11
R12
R13
R14
R15
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/16SS153J
RS1/16SS0R0J
RS1/16SS0R0J
RS1/16SS153J
RS1/10SR103J
L7
L8
L11
FB1
FB2
INDUCTOR
INDUCTOR
POWER INDUCTOR
CHIP BEAD
CHIP BEAD
142000000333-FY
142000000333-FY
142000000116-FY
142040000039-FY
142040000012-FY
R16
R17
R18
R19
R20
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/10SR103J
RS1/10SR101J
RS1/16SS103J
RS1/16SS103J
RS1/16SS103J
FB3
FB4
FB5
FB6
FB8
CHIP BEAD
CHIP BEAD
CHIP BEAD
CHIP BEAD
CHIP BEAD
142040000039-FY
142040000054-FY
142040000006-FY
142040000006-FY
142040000039-FY
R21
R23
R24
R25
R26
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/16SS103J
RS1/16SS473J
RS1/16SS103J
RS1/16SS103J
RS1/16SS103J
FB15
FB16
FB17
FB18
FB19
CHIP BEAD
CHIP BEAD
CHIP BEAD
CHIP BEAD
CHIP BEAD
142040000012-FY
142040000039-FY
142040000012-FY
142040000012-FY
142040000012-FY
R27
R28
R29
R30
R31
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/16SS103J
RS1/16SS104J
RS1/16SS223J
RS1/16SS223J
RS1/8SQ0R0J
FB20
FB21
FB22
FB23
TX1
CHIP BEAD
CHIP BEAD
RESISTOR
RESISTOR
TCXO 27MHz
142040000054-FY
142040000054-FY
RS1/16SS0R0J
RS1/16SS0R0J
142825000059-FY
R32
R33
R34
R35
R36
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/10SR102J
RS1/10SR333J
RS1/10SR102J
RS1/16SS103J
RS1/16SS103J
TX2
TC1
TC2
TC3
TC4
TCXO 12MHz
TAN.CAP
TAN.CAP
TAN.CAP
CAPACITOR
142825000105-FY
141845040107-FY
141845040107-FY
141845040107-FY
141806020106-FY
R37
R38
R39
R40
R41
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/10SR2001F
RS1/10SR2001F
RS1/16SS103J
RS1/16SS103J
RS1/8SQ1R0J
TC5
TC6
TC7
TC8
TC9
TAN.CAP
SMD E-CAP
SMD E-CAP
TAN.CAP
TAN.CAP
141845040107-FY
141827000107-FY
141827000107-FY
141845010476-FY
141845040107-FY
R42
R43
R44
R45
R46
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/16SS0R0J
RS1/16SS103J
RS1/16SS103J
RS1/16SS103J
RS1/16SS750J
TC10
TC11
SC1
SR1
SR2
SMD E-CAP
SMD E-CAP
CAPACITOR
RESISTOR
RESISTOR
141827000107-FY
141827000107-FY
141803000225-FY
RS1/16SS472J
RS1/16SS473J
R47
R48
R49
R50
R51
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/16SS750J
RS1/16SS750J
RS1/16SS5102F
RS1/16SS223J
RS1/16SS5102F
SR3
SR4
RP1
K1
CN1
RESISTOR
RESISTOR
NET RES
END-SENSE SW
FFC SOCKET
RS1/10SR222J
RS1/10SR102J
RAB4CQ101J
143210000004-FY
143815000047-FY
R52
R53
R54
R55
R56
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/16SS5102F
RS1/16SS1502F
RS1/10SR330J
RS1/10SR0R0J
RS1/10SR0R0J
CN3
CN6
WIRE HARNES
FPC SOCKET
123835000874-FY
143800000019-FY
R57
R58
R59
R60
R61
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/16SS101J
RS1/16SS101J
RS1/10SR391J
RS1/8SQ0R0J
RS1/16SS102J
R62
R63
R64
R65
R66
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/8SQ2R2J
RS1/16SS103J
RS1/16SS102J
RS1/16SS102J
RS1/10SR750J
A
B
C
RESISTORS
R1
R2
R3
R4
R5
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/8SQ100J
RS1/8SQ100J
RS1/10SR221J
RS1/10SR221J
RS1/16SS222J
DVH-840AVBT/XEUW5
5
6
7
8
D
E
F
83
1
Circuit Symbol and No.
A
B
2
3
Part No.
R67
R68
R69
R70
R71
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/16SS102J
RS1/16SS221J
RS1/16SS103J
RS1/10SR750J
RS1/16SS103J
R72
R73
R74
R75
R76
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/10SR102J
RS1/10SR151J
RS1/10SR750J
RS1/16SS102J
RS1/16SS750J
R77
R78
R79
R81
R82
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/16SS103J
RS1/10SR750J
RS1/16SS153J
RS1/16SS750J
RS1/16SS103J
R83
R84
R85
R86
R87
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/10SR472J
RS1/16SS473J
RS1/16SS472J
141604006191-FY
RS1/8SQ750J
R88
R89
R90
R91
R92
RESISTOR
NET RES
RESISTOR
RESISTOR
RESISTOR
RS1/16SS221J
RAB4CQ102J
RS1/16SS103J
RS1/16SS470J
RS1/10SR4R7J
R93
R94
R95
R96
R97
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/10SR472J
RS1/10SR472J
RS1/10SR562J
RS1/10SR562J
RS1/10SR153J
R98
R99
R100
R101
R102
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/10SR153J
RS1/10SR332J
RS1/10SR332J
RS1/8SQ151J
RS1/10SR473J
R103
R104
R105
R106
R107
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/10SR473J
RS1/10SR102J
RS1/10SR102J
RS1/16SS102J
RS1/16SS102J
R108
R109
R115
R116
R117
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/16SS472J
RS1/16SS103J
RS1/16SS101J
RS1/16SS103J
RS1/10SR223J
R118
R119
R120
RESISTOR
RESISTOR
RESISTOR
RS1/10SR223J
RS1/10SR472J
RS1/10SR473J
C
D
E
CAPACITORS
F
C1
C2
C3
C4
C5
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
141806020106-FY
CKSSYB104K10
CKSRYB273K25
CKSSYB104K10
CKSSYB104K10
C6
C7
C8
C9
C10
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CKSSYB104K10
CKSRYB273K25
CKSSYB104K10
CKSSYB103K25
CKSSYB104K10
84
4
Circuit Symbol and No.
Part No.
C11
C12
C13
C14
C15
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CKSSYB104K10
CKSSYB104K10
141806020106-FY
CKSSYB104K10
CKSRYB104K16
C16
C17
C18
C20
C21
SMD E-CAP
SMD E-CAP
CAPACITOR
CAPACITOR
SMD E-CAP
141827000107-FY
141827020476-FY
CKSSYB104K10
CKSSYB104K10
141827020476-FY
C22
C23
C24
C25
C26
SMD E-CAP
CAPACITOR
SMD E-CAP
CAPACITOR
SMD E-CAP
141827000107-FY
CKSSYB104K10
141827000107-FY
CKSSYB104K10
141827010106-FY
C27
C28
C29
C31
C32
SMD E-CAP
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
141827000107-FY
CKSSYB104K10
CKSSYB104K10
CKSSYB102K50
CKSSYB102K50
C33
C34
C35
C36
C37
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CKSSYB104K10
CKSSYB104K10
CKSSYB104K10
CKSSYB104K10
CKSRYB102K50
C38
C39
C40
C42
C43
CAPACITOR
CAPACITOR
CAPACITOR
TAN.CAP
CAPACITOR
CKSRYB102K50
CKSSYB104K10
CKSSYB104K10
141845010476-FY
CKSSYB104K10
C44
C45
C46
C47
C48
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
141803000151-FY
CKSSYB104K10
CCSSCH330J50
CCSRCH100D50
CKSSYB104K10
C49
C50
C51
C52
C53
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CCSSCH330J50
CCSRCH100D50
141803000151-FY
CKSSYB104K10
141809010106-FY
C54
C55
C56
C57
C58
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CKSSYB104K10
CKSSYB104K10
CCSRCH100D50
141803000151-FY
CCSRCH100D50
C59
C60
C61
C62
C63
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
141803000151-FY
CKSSYB104K10
CCSRCH101J50
CCSSCH220J50
CKSSYB104K10
C64
C65
C66
C67
C68
CAPACITOR
CAPACITOR
CAPACITOR
TAN.CAP
CAPACITOR
CCSSCH220J50
CKSSYB104K10
CKSSYB104K10
141845040106-FY
CKSSYB104K10
C69
C70
C71
C72
C73
CAPACITOR
CAPACITOR
TAN.CAP
CAPACITOR
CAPACITOR
CKSSYB104K10
CKSSYB104K10
141845040106-FY
CKSSYB104K10
CKSSYB104K10
DVH-840AVBT/XEUW5
1
2
3
4
5
6
Circuit Symbol and No.
7
Part No.
Circuit Symbol and No.
8
Part No.
C74
C75
C76
C77
C78
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CKSSYB104K10
CKSSYB104K10
CKSSYB104K10
CKSSYB104K10
CKSSYB104K10
Q207
D201
D222
D223
D224
TRANSISTOR
SCHOTTKY DIODE
ESD DIODE
ESD DIODE
ESD DIODE
142245000077-FY
142233000026-FY
142239000012-FY
142239000012-FY
142239000012-FY
C79
C80
C82
C83
C84
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CKSSYB104K10
CKSQYB225K16
141806000226-FY
141806000226-FY
CKSSYB104K10
D225
D226
D227
D228
D229
ESD DIODE
ESD DIODE
ESD DIODE
ESD DIODE
ESD DIODE
142239000012-FY
142239000012-FY
142239000012-FY
142239000012-FY
142239000012-FY
C85
C86
C87
C88
C89
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CKSSYB104K10
CKSSYB104K10
CKSSYB104K10
CKSSYB104K10
CKSSYB104K10
D230
D231
D232
D234
D235
ESD DIODE
REC DIODE
SCHOTTKY DIODE
DUAL DIODE
DUAL DIODE
142239000012-FY
142206000003-FY
122233000012-FY
142236000005-FY
142236000005-FY
C90
C91
C92
C93
C94
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CKSSYB104K10
CKSRYB152K50
CKSRYB152K50
CKSRYB272K50
CKSRYB272K50
D236
D238
D240
D241
D242
SCHTTKY DIODE
ESD DIODE
ESD DIODE
ESD DIODE
ESD DIODE
142233000006-FY
142239000012-FY
142239000012-FY
142239000012-FY
142239000012-FY
C95
C96
C97
C98
C99
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CKSRYB221K50
CKSRYB221K50
141806020106-FY
141806020106-FY
CKSSYB104K10
D251
D252
D253
D254
L201
ESD DIODE
ESD DIODE
ESD DIODE
ESD DIODE
CHIP BEAD
142239000012-FY
142239000012-FY
142239000012-FY
142239000012-FY
142040000012-FY
C100
C101
C102
C103
C104
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CKSSYB104K10
CKSSYB104K10
CKSSYB104K10
CKSSYB104K10
CKSSYB104K10
L202
L203
L204
L205
L206
POWER INDUCTOR
CHIP BEAD
POWER INDUCTOR
POWER INDUCTOR
INDUCTOR
142000000423-FY
142040000012-FY
122000000315-FY
122000000315-FY
142000000028-FY
C105
C106
C107
C110
C111
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CKSSYB104K10
CKSSYB104K10
CKSSYB104K10
CKSRYB823K50
CKSRYB823K50
L207
L208
L209
L210
L211
INDUCTOR
CHIP BEAD
INDUCTOR
INDUCTOR
INDUCTOR
142000000028-FY
142040000012-FY
142000000055-FY
142000000007-FY
142000000007-FY
C112
C113
CAPACITOR
CAPACITOR
141806020106-FY
141806020106-FY
L212
L214
L215
L219
L220
INDUCTOR
POWER INDUCTOR
CHIP BEAD
INDUCTOR
INDUCTOR
142000000028-FY
142000000423-FY
142040000039-FY
142000000028-FY
142000000028-FY
L226
L227
L228
L232
L235
INDUCTOR
INDUCTOR
CHIP BEAD
CHIP BEAD
CHIP BEAD
142000000028-FY
142000000028-FY
142040000012-FY
142040000012-FY
142040000012-FY
L236
L237
L238
L239
L240
CHIP BEAD
CHIP BEAD
CHIP BEAD
CHIP BEAD
CHIP BEAD
142040000012-FY
142040000012-FY
142040000012-FY
142040000012-FY
142040000012-FY
A
B
C
D
KB Assy
Consists of
KB PCB
AUX PCB
CD
Unit Number :
Unit Name
: KB Assy
MISCELLANEOUS
U201
U202
U204
U205
U206
IC
IC
IC
IC
IC
142410001016-FY
142400001207-FY
142400000282-FY
142400001048-FY
142400001047-FY
L241
L242
L243
BD201
BD202
CHIP BEAD
CHIP BEAD
CHIP BEAD
CHIP BEAD
CHIP BEAD
142040000012-FY
142040000012-FY
142040000012-FY
142040000061-FY
142040000061-FY
U207
Q200
Q201
Q202
Q206
IC
MOSFET
TRANSISTOR
TRANSISTOR
MOSFET
142400001422-FY
142266000075-FY
142245000017-FY
142245000077-FY
142266000075-FY
BD203
BD204
BD205
LED201A
LED201G
CHIP BEAD
CHIP BEAD
RESISTOR
LED
LED
142040000061-FY
142040000061-FY
RS1/8SQ0R0J
143405010069-FY
143405000084-FY
DVH-840AVBT/XEUW5
5
6
7
8
E
F
85
1
Circuit Symbol and No.
A
B
C
2
3
Part No.
LED202A
LED202G
LED203A
LED203G
LED204A
LED
LED
LED
LED
LED
143405010069-FY
143405000084-FY
143405010069-FY
143405000084-FY
143405010069-FY
LED204G
LED205A
LED205G
LED208A
LED208G
LED
LED
LED
LED
LED
143405000084-FY
143405010069-FY
143405000084-FY
143405010069-FY
143405000084-FY
LED209A
LED209G
LED210A
LED210G
LED211A
LED
LED
LED
LED
LED
143405010069-FY
143405000084-FY
143405010069-FY
143405000084-FY
143405010069-FY
LED211G
LED212A
LED212G
X201
ZD102
LED
LED
LED
TCXO 33.8688MHz
ZENER DIODE
143405000084-FY
143405010069-FY
143405000084-FY
142825000208-FY
142224000010-FY
ZD201
ZD202
ZD203
ZD237
ZD238
ZENER DIODE
ZENER DIODE
ZENER DIODE
ZENER DIODE
ZENER DIODE
142224000085-FY
142224000093-FY
142224000024-FY
142224000018-FY
142224000018-FY
ENC201
SW201
SW202
SW203
SW204
ENCODER(MULTI-CONTROL) 141658010116-FY
TACT SW
143210000016-FY
TACT SW
143210000016-FY
TACT SW
143210000016-FY
TACT SW
143210000016-FY
SW205
SW206
SW207
SW208
SW209
TACT SW
TACT SW
TACT SW
TACT SW
TACT SW
143210000016-FY
143210000016-FY
143210000016-FY
143210000016-FY
143210000016-FY
SW210
REM201
USB201
CON1
CON201
TACT SW
INFRARED RECEIVER
SOCKET
SOCKET
CONNECTOR
143210000016-FY
143445000037-FY
123805000787-FY
123805000879-FY
123800000317-FY
CON202
FFC SOCKET
143815000067-FY
D
RESISTORS
E
F
R200
R201
R202
R203
R204
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/8SQ0R0J
RS1/10SR102J
RS1/10SR122J
RS1/10SR102J
RS1/10SR102J
R205
R206
R207
R208
R209
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/10SR152J
RS1/10SR182J
RS1/10SR222J
RS1/10SR332J
RS1/10SR392J
R210
R211
R212
R213
R214
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/10SR562J
RS1/10SR102J
RS1/10SR122J
RS1/10SR102J
RS1/10SR152J
86
4
Circuit Symbol and No.
Part No.
R215
R216
R217
R218
R219
RESISTOR
RESISTOR
RESISTOR
RESISTOR
CHIP BEAD
RS1/10SR182J
RS1/10SR222J
RS1/10SR332J
RS1/10SR203J
142040000012-FY
R220
R221
R222
R223
R225
CHIP BEAD
RESISTOR
RESISTOR
RESISTOR
RESISTOR
142040000012-FY
RS1/10SR103J
RS1/10SR103J
RS1/10SR104J
RS1/10SR103J
R226
R227
R228
R230
R231
RESISTOR
RESISTOR
CHIP BEAD
RESISTOR
RESISTOR
RS1/10SR471J
RS1/10SR202J
142040000012-FY
RS1/10SR103J
RS1/10SR103J
R232
R233
R234
R235
R236
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/10SR103J
RS1/10SR102J
RS1/8SQ101J
RS1/10SR101J
RS1/10SR103J
R237
R238
R239
R240
R241
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/10SR103J
RS1/10SR102J
RS1/10SR103J
RS1/8SQ102J
RS1/10SR472J
R242
R243
R244
R245
R246
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/8SQ0R0J
RS1/8SQ471J
RS1/8SQ471J
RS1/8SQ471J
RS1/8SQ471J
R247
R248
R249
R250
R251
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/8SQ471J
RS1/10SR102J
RS1/10SR102J
RS1/10SR6800F
RS1/10SR5101F
R252
R253
R255
R256
R258
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
141608019024-FY
RS1/10SR181J
RS1/10SR0R0J
RS1/8SQ511J
RS1/10SR203J
R259
R260
R261
R262
R263
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/10SR821J
RS1/10SR103J
RS1/10SR821J
RS1/10SR103J
RS1/10SR821J
R264
R266
R267
R268
R269
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/10SR103J
RS1/10SR103J
RS1/10SR103J
RS1/10SR103J
RS1/10SR121J
R270
R271
R272
R273
R274
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/10SR750J
RS1/10SR750J
RS1/10SR750J
RS1/10SR103J
RS1/10SR472J
R275
R276
R277
R278
R279
RESISTOR
NET RES
NET RES
NET RES
RESISTOR
RS1/10SR223J
RAB4C330J
RAB4C330J
RAB4C330J
RS1/10SR103J
DVH-840AVBT/XEUW5
1
2
3
4
5
Circuit Symbol and No.
6
7
Part No.
8
Circuit Symbol and No.
Part No.
R280
R281
R284
R285
R286
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/10SR103J
RS1/10SR562J
RS1/10SR472J
RS1/10SR102J
RS1/8SQ680J
C243
C244
C248
C249
C251
CAPACITOR
CAPACITOR
E.CAP
CAPACITOR
E.CAP
CKSRYB104K16
141809040106-FY
141842070107-FY
CKSRYB104K16
141842070107-FY
R287
R288
R289
R290
R291
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RESISTOR
RS1/8SQ151J
RS1/10SR473J
RS1/8SQ331J
RS1/10SR473J
RS1/10SR103J
C252
C253
C254
C255
C256
CAPACITOR
E.CAP
CAPACITOR
CAPACITOR
CAPACITOR
CKSRYB681K50
141842070107-FY
141809040106-FY
CKSRYB104K16
CKSRYB104K16
R292
R293
R295
R296
R297
RESISTOR
CHIP BEAD
RESISTOR
RESISTOR
RESISTOR
RS1/8SQ680J
142040000039-FY
RS1/10SR103J
RS1/10SR102J
RS1/10SR153J
C257
C258
C259
C277
C278
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CKSRYB104K16
CKSRYB104K16
141809040106-FY
CKSYB225K25
CKSRYB104K16
R298
R299A
RESISTOR
RESISTOR
RS1/10SR103J
RS1/10SR102J
C279
C280
C281
C282
C283
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
E.CAP
CKSRYB104K16
141812010226-FY
CKSRYB104K16
141812010226-FY
141842070107-FY
C285
C291
C292
C294
C295
CAPACITOR
CAPACITOR
CAPACITOR
E.CAP
E.CAP
CCSRCH101J50
CKSQYB225K16
CKSRYB104K16
141842070107-FY
141842070107-FY
C296
E.CAP
141842070107-FY
CAPACITORS
C201
C202
C203
C204
C205
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CKSRYB103K50
CKSRYB103K50
141812010226-FY
CKSRYB104K16
CKSRYB102K50
C206
C207
C208
C209
C210
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CKSRYB102K50
CKSRYB331K50
CKSRYB681K50
141803040105-FY
CCSRCH330J50
C211
C212
C213
C214
C215
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CCSRCH330J50
141803040105-FY
CCSRCH330J50
CCSRCH330J50
141803040105-FY
C218
C219
C220
C221
C222
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CKSRYB102K50
CKSRYB104K16
CCSRCH330J50
CCSRCH330J50
CKSRYB104K16
C223
C224
C225
C226
C227
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CKSRYB104K16
CKSRYB104K16
CKSRYB104K16
141809010106-FY
CKSRYB104K16
LED1
LED2
SW1
SW2
SW3
LED
LED
TACT SW
TACT SW
TACT SW
143405010069-FY
143405010069-FY
123210010125-FY
143210010096-FY
143210000097-FY
C228
C229
C230
C231
C232
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CKSRYB105K16
141812010226-FY
CKSRYB104K16
CKSQYB225K16
141812010226-FY
CN406
CON1
FPC SOCKET
CONNECTOR
123800010040-FY
123800020170-FY
C233
C234
C235
C236
C237
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CKSRYB104K16
141812010226-FY
CKSRYB104K16
CKSRYB104K16
CKSRYB104K16
C238
C239
C240
C241
C242
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
CAPACITOR
141803040105-FY
141803040105-FY
141803040105-FY
CKSQYB225K16
141809040106-FY
6
B
C
CB/LB Assy
Consists of
CB PCB
LB PCB
EF
Unit Number :
Unit Name
D
: CB/LB Assy
MISCELLANEOUS
DVH-840AVBT/XEUW5
5
A
E
F
7
8
87