Download Service Manual - Manuales de Service

DVD Portable Player
DCP851
All version
Service Manual
TABLE OF CONTENTS
Chapter
Technical Specification & Service Tips…………..……….. 1
Safety Instructions…………………………………………….. 2
Instruction for Use……………………………………………… 3
Mechanical Instructions………………………………………. 4
Troubleshooting …………………………………………………5
Overall Block Diagram…………………………………………. 6
Electrical Diagram……………………………………………… 7
Service Part List………………………………...………………. 8
Revision List……………………………………………………. 9
©Copyright 2005 Philips Consumer Electronics B.V. Eindhoven, The Netherlands
All rights reserved. No part of this publication may by reproduced, stored in a
retrieval system or transmitted, in any form or by any means, electronics,
mechanical, photocopying, or otherwise without the prior permission of Philips
3141 785 32601
Version 1.1
1.0 TECHNICAL SPECIFICATION
General
Dimensions (W x H x D):
Bear Unit Weight:
Power supply:
Supply voltage
Supply Power
consumption (AC adaptor
100/240VAC)
Operating Temperature
Video System
Frequency response
THD 20-20kHz (%):
Dynamic range 1kHz
Signal/Noise ratio:
Channel Separation 1kHz
Channel Balance 1kHz
Playback disc type:
DVD, Picture-CD,
SVCD, Video CD, MP3CD, CD-R/CD-RW,
WMA-CD, DVD-R, DVDRW, DVD+R, DVD+RW
Video Playback Format:
DVD / VCD / SVCD / CD
/ JPEG / Divx
Audio Playback Format:
CD/MP3, MP3-DVD,
DVD, Divx
Card slot:
SD / MMC (memory up
to 1GB)
Disc Diameter
12cm
210 x 39 x 178 mm
1.1 kg +/- 5%
Input: 100~240V + / - 10%
50/60Hz 0.3A
Output: DC 9V 1A
9W + 10%
-10 ~ 50degC
NTSC
20-20kHz +/-1dB
</=3%
>/=80dB
>/=80dB
>=60dB
<3dB
Pixel specification
Max. 0 bright-dot & max. 3 dark-dots
Current consumption
Playback time
Capacity--- Refer to battery
spec
Battery discharge cut-off
current
Max.battery charge
current(continue charge) of
DCP850 & DCP750
Charging time
2400mAH
40mA
450mA
5 +/- 0.5H
Headphone out (headphone output load 2x16 ohm)
Maximum output power:
Frequency response:
SNR (A-wght):
THD (0.2-20kHz):
Left-Right Channel
Separation:
Left-Right Channel
Balance:
Factory Service Mode (FSM)
1.5mW
+/-3dB
>65dB
3%
>/=50dB
To check the software version and change
region code of your DVD Portable
1. Power ON the DVD player and open the DVD
door
2. Press the “SETUP” button on remote control,
then select the “Preference MENU”
3. Press the remote button in the sequence as
9 -> 6 -> 5 -> 3
4. The LCD display showed the existing region
code. Press
(navigation up) or
(navigation down) repeatedly to select the
number from 0 to 6.
5. Refer below table for your region code setting
</=1dB
Supported disc type
Select “0” setting = Region Free (confidential)
Video Playback
Formats:
Audio Playback
Formats:
1.0 TECHNICAL SPECIFICATION
Procedure on how to upgrade the software of
the DVD Portable
For the best performance of your DVD Portable.
Check www.philips.com/support for latest
software upgrades available.
A) By CD-ROM
1.
2.
3.
4.
5.
Download the “PHILIPS.BIN” file from the Philips
support site
Unzip the file and then burn it into a CD-ROM to
make a disc for upgrade
CD-ROM disc name must be “PHILIPS”
(otherwise it will not be recognized as a disc for
upgrade)
Power on the Portable DVD Player with AC/DC
adaptor
Play CD-ROM for firmware upgrade
Warning: Do not unplug the AC adaptor during
firmware upgrade to prevent flash corrupt of the
set!!
6.
7.
Once upgrade is completed, the player will restart
automatically and observed PHILIPS LOGO on the
screen.
Open the DVD door to remove the disc
B) By SD Card
1.
2.
3.
4.
Download the “PHILIPS.BIN” file from the Philips
support site
Unzip the file and then copy and paste it into a
blank SD card
Power on the Portable DVD Player with AC/DC
adaptor
Read the SD card via SD Card slot for firmware
upgrade
Warning: Do not unplug the AC adaptor during
firmware upgrade to prevent flash corrupt of the
set!!
5.
Once upgrade is completed, the player will restart
automatically and observed PHILIPS LOGO on the
screen.
1.0 TECHNICAL SPECIFICATION
Service Policy on PCBA of DCP851
Type
Main PCBA
TFT PCBA
KEY PCBA
BATTERY PCBA
IPOD PCBA
MLR = module swap
/05
MLR
MLR
MLR
MLR
MLR
/12
MLR
MLR
MLR
MLR
MLR
/37
MLR
MLR
MLR
MLR
MLR
/98
MLR
MLR
MLR
MLR
MLR
3.0 INSTRUCTION FOR USE
3.0 INSTRUCTION FOR USE
4.0 MECHANICAL INSTRUCTION
Disassembly Procedure
1. Remove 7pcs of screws on the side of bottom
cabinet.
2. Open the bottom cabinet. Carefully unplug the
housing which is connected with main board
and TFT board.
3. Open the bottom cabinet.
First, unplug all the housing which are connected
the main board with battery board, key board and
IPOD board. (include 2pcs housing and the FFC
for the DVD louder)
Second, unplug all the housing which are
connected with main board and TFT board (then
you can separate TFT board and main board)
Remove all the screws on the main board (4pcs),
take out the main board from bottom cabinet.
4.0 MECHANICAL INSTRUCTION
4. Unplug the FFC and remove 3pcs screws from
DVD louder, then you can take out the DVD
louder.
5. From this location (between the buttons and
battery) you can take out the key board easily.
6. Remove 2pcs of screws on the battery board.
You can’t take out the battery together with the
battery board yet. Due to the battery was fixed
by the IPOD plastic docking cover and the
press IPOD-lock metal piece.
If you want to take out the battery, you must
remove the IPOD plastic docking cover and the
press IPOD-lock metal piece first.
Remove 4pcs screws from the cover (shown the
left photo), after that remove these 2pcs screws
(as shown the above photo).
Note: the battery was fixed by 2pcs two side
adhesive tape!
4.0 MECHANICAL INSTRUCTION
After done above, you can take out the IPOD
plastic docking cover and IPOD docking.
7. Unplug all the housing which are connected
with main board and TFT board (don’t forget to
unplug the Panel FFC from TFT board behind
the black flannel).
8. Remove 6pcs screws on the TFT board, desoldering the wire connected between panel and
TFT board (don’t forget to de-soldering the black
ground wire). Then take out the TFT board
from display frame.
Remove 4pcs screws which are to fix the panel on
the display frame to take out the panel from
display frame.
To take out the IPOD board.
Remove 2pcs black screws from the bottom of IPOD
docking(as the photo shown)
4.0 MECHANICAL INSTRUCTION
5.0 TROUBLESHOOTING
SYMPTOM: BATTERY NO POWER
BATTERY CAN＇T
Power ON
Start
Check Battery capacity?
no
Check charging
function OK?
Check adaptor
power-ON OK?
Yes
yes
SET OK?
Yes
No
Check the Power-ON
button and cable OK?
NO
Replace Button or
Cable
No
Yes
Replace Main Board
No Defect, return
set to Customer
5.0 TROUBLESHOOTING
SYMPTOM: NO IMAGE / NO SOUND
SYMPTOM: NO IMAGE OUTPUT ( THE PANEL SHOW BLUE PICTURE)
Start
Check DVD Drive work?
no
Replace DVD Drive
no
Exchange AV cable
yes
NOTE: AV Cable TYPE from outside to
Inside L-Audio, R-Audio, Video, Ground
Check the external AV
Cable TYPEnote and
connection is OK?
yes
Replace Main Board
SYMPTOM: NO SOUND COMES FROM SPEAKER
Start
Check the Connection OK?
no
Reinsertion
no
Change the speaker
yes
Check speaker OK?
yes
Replace Main Board
5.0 TROUBLESHOOTING
SYMPTOM: THE DVD DRIVE DOES NOT WORK
SYMPTOM: THE DVD DRIVE DOESN＇T WORK
Start
Check DVD-Loader
connection OK?
NO
Cable Reinsertion
NO
Replace DVDLoader
Yes
Check the DVD-Loader
OK?
Yes
Replace main board
5.0 TROUBLESHOOTING
SYMPTOM: ADAPTOR CANNOT POWER ON
Adaptor can not Power ON
Start
Check Adaptor OK?
NO
Change adaptor
SET OK?
Yes
Yes
No
Check the Power-ON
button and cable OK?
YES
Return set to
Customer
Replace Main Board
NO
Replace Button or
Cable
OK
5.0 TROUBLESHOOTING
SYMPTOM: REMOTE CONTROL CANNOT WORK
SYMPTOM: THE REMOTE CONTROL CAN NOT
WORK
Start
Check CABLE form
bottom board to top board
connection OK?
NO
Cable Reinsertion
NO
Replace IR receiver
Yes
Check TOP-board OK?
NO
Replace top board
OK
Yes
OK
Replace main board
OK
Return to custormer
5.0 TROUBLESHOOTING
SYMPTOM: NO SOUND FROM HEADPHONE
5.0 TROUBLESHOOTING
SYMPTOM: LED DISPLAY FAILURE
SYMPTOM: LED Display Fail
Start
Check CABLE form Main board to top board
connection OK?
NO
Cable Reinsertion
Yes
Check TOP-board OK?
NO
Replace LED
NO
Replace top board
OK
Yes
OK
Replace main board
OK
Return to custormer
5.0 TROUBLESHOOTING
SYMPTOM: KEY & BOTTON FAILURE
SYMPTOM: Key & Botton Fail
Start
Check CABLE form board to
board connection OK?
NO
Cable Reinsertion
Yes
Check KEY board OK?
NO
OK
Yes
Replace main board
Replace KEY board
OK
Return to custormer
6.0 BLOCK DIAGRAM
7.0 ELECTRICAL DIAGRAM
The diagrams listed on the following pages:
Part 1 – Schematic diagram of MAIN BOARD (7 pages)
Part 2 – Schematic diagram of TFT DRIVER BOARD AND KEY BOARD (3 pages)
Part 3 – Schematic diagram of IPOD BOARD (1 page)
Part 4 – PCBA layout diagram of MAIN BOARD (2 pages – top and bottom side)
Part 5 – PCBA layout diagram of TFT DRIVER BOARD (2 pages – top and bottom side)
Part 6 – PCBA layout diagram of KEY BOARD (2 pages – top and bottom side)
Part 7 – PCBA layout diagram of IPOD BOARD (2 pages – top and bottom side)
Part 8 – PCBA layout diagram of BATTERY BOARD (2 pages – top and bottom side)
4
3
2
1
J10
DC_IN
8.4V_CHARGE
D5
10K
R6
Q30
3904
Q5
3904
SWC
SW1
SW2
SW1
SW2
10K
560
2
1
R7
SK34
2x1
15V
2
R22
3904
L1
+
SSP0403STR
Q8
C2
100UF/25V
+3.3VS
FB 600R
EEC1
+
NC/100u/10V
J12
H
R99
OUT L
R145 4k7
POWER_PRE
Q14
BAT54C
+3.3
3904
4.7K
R101
R220
EC12
10K
10K
10u/10V
POWER_PRE
2
CHARG_PRE
RLS4148
1
Q33
FB 600R
R216 560
+3.3VDDC
FB 600R
EC3
+
100u/10V
100n
10K
4.7K
1.5K
L3
R192
3904
R?
R222
4.7K
L2
+3.3
C4
R224 4.7K
C
R?
SGND
I/O 1 ON/OFF DRIVE
2
+3.3
D16 NC
R221
3.9K
R223
4.7K
1
EC2
+
100n
Q32
3904
R160
10K
D11
C3
IN
1
100n
Q22
2
3904
Q4
9v-in
2
D8
1
CB1
2
4001
10K
1
10K
15V
2
R1
CHARG_PRE
R218 560
Q31
1
100u/10V
DGND
DGND
L4
R11
R12
10K
10K
3
B
Low Voltage Det
R13
S
100n
C
+3.3V
FB 600R PCB NC
+3.3
C5
+9VIN
2D
DGND
+3.3
33K 1%
Q11
E
R14
3904
4.7K
C
I/O 2ON/OFF DET
Q20
3904
1
G
C1
2
+3.3
1
0.1u
3
D7
1
1
2
FUSE
VCC
D
3904
D16
3.3V
0.1u
DC_IN
CB2
1
Q6
3904
D6
T1 CON
3
F1
4
J1
DC JACK
122
D13
2
POWER OFF
B-CHARG
Q7
GREEN
D1
10K
SK34
POWER ON
1K
1
R219
1
D2
R89
Q2
SSP0403STR
1
13V
2
Discharge
D
SSP0403STR
Q3
R4
10K
R2
R3
1
2
3
4
5
1K
15V
2
PIN HEADER 1X4
D3
5
L6
Q12
3
+5VD
3904
+5V
+ EC4
FB 600R
R15
C11
EC8
C6
100uF/10V
IN
2
0.1uF
+1.8V
L5 FB 600R
U1
OUT
1
GND
C8
1117-1.8V
0.1uF
+
+ EC5
EC1
47uF/10V
C7
47uF/10V
0.1uF
3K6 1%
100u/10V
100n
GND
L9
5VM
+5V
FB 600R
EC11
+
C20
100u/10V
100n
MGND
B
8.4V_CHARGE
C149
C14
0.1uF
R203
10
560P
100uF/25V
C150
1uF(0805)
SGND
VIN
1
CE
GND
R206
NC
GND
560
R206
3
VFB
Low Voltage Det 2
EC65
470uF/6.3v
GND
R204 22K
1
2
CP
10K
C149
GND
30K
0.1uF
R202
10
EC64
+
100uF/25V
560P
GND
4
GREEN
POWER ON
INDICATION
0.1uF
GND
D17
GND
C148
1uF(0805)
GND
5
VIN
1
CE
U14
SS7701
+5V
C157
+
C150
1uF(0805)
EC66
470uF/6.3v
0.1uF
GND
GND
GND
5
VIN
1
CE
U13
SS7701
L6
22uH
C152
NC
GND
560
R206
3
470uF/6.3v
0.1uF
GND
R206
VFB
EC65
+
GND
R204 22K
1
R208
R205 2.7K
2
C151 1000P
10K
GND
GND
NC
GND
18K
R211 22K
R213
3
GND
22uH
R214
VFB
NC
100uF/25V
4
L4
Q28 SSP0403STR
2
3
C158
R199
10
1
1K
R198
10
EC63
+
GND EXT
R260
C159
D22 SS14
+3.3
R203
10
GND
GND
+3.3V
Q29 SSP0403STR
2
3
C153
C151 1000P
R205 2.7K
R208
D21 SS14
1uF
100P
68K
SK34
1uF
C24
R21
U13
SS7701
GND
FB2
5
GND EXT
4
GND
GND
GND
+
2
+
100n
C152
0.1uF
GND
A
1
2
2
1
10uF/16V
8.4V_CHARGE 5
Low Voltage Det
22uH
L6
1
EC9
SGND
R202
10
EC64
+
+3.3V
Q29 SSP0403STR
2
3
C153
L11 22uH
VDD
10uH 4532
2,5
GND EXT
+9VIN
L7
+5V
120K R22
C21
2
SSP0403STR
SWC
2
1
C25
100n
D21 SS14
10uF/25V
C26
100n
+5V
L10 22uH
NC
A
+
R20
+
100u/10V
13K
3
Q14
C23
SCP
FB2
+9VIN
D11
SS2
12
4
6
C22 NC
5
FB2
SW2
EC13 100uF/10V
0.01uF
EN2
COMP1
SS1
COMP2
FB 600R PCB NC
EC14
R17
3
EC12 100uF/25V
C19
14
+3.3VSTB
SWC
30K
10
0.01uF
33K
B
+3.3VSTB
+5V
FB1
1uF
27K
C17
R19
C13
R18
+
100uF/10v
3300P
3300P
EC7
C16
C18
NC
EN1
+
SK34
1
2
FB1
1uF
11
13
C15
FB1
SW1
EC10 100uF/25V
VIN
VG
GND
D10
7
8
9
C12
C10 1uF
C9 0.1uF
EC6
+
+3.3
RFVCC
L11
+3.3
22uH
R16
U2 AT1793SOP-14
+9VIN
L8
SSP0403STR
3
2
1
Q13
+9VIN
R215
R212 2.7K
C156 1000P
10K
GND
GND
Title
Size
D
5
4
3
2
Date:
MAIN BOARD
Document Number
1
DCP851&951
Thursday, December 06, 2007
Sheet
1
Rev
Ver 1.0
of
9
D
MDQM
MCLK
/WE
/CAS
/RAS
/CS0
MBA0
MBA1
R55
+1.8V
+3.3VDDC
MD7
MD6
MD5
MD4
MD3
MD2
MD1
MD0
MDQM
MCLK
/WE
/CAS
/RAS
/CS0
MBA0
MBA1
MD8
MD9
MD10
MD11
MD12
MD13
MD14
MD15
MA[0..12]
4
4
4
4
4
4
4
4
MA4
MA5
MA6
MA7
MA8
MA9
MA11
MA12
MD[0..15]
4
MA3
MA2
MA1
MA0
MA10
4
1
2
3
4
5
0
114PIN
113PIN
100n
C63
C64
C65
C66
C67
C68
100n
100n
100n
100n
100n
100n
100n
D
114PIN
113PIN
AGND
AGND
VAMP
C69
C62
AGND
AMP_B
AMP_G
+3.3VDDC
+1.8V
+3.3VV
162
161
160
159
158
157
156
155
154
153
152
151
150
149
148
147
146
145
144
143
142
141
140
139
138
137
136
135
134
133
132
131
130
129
128
127
126
125
124
123
122
121
120
119
118
117
116
115
114
113
112
111
110
109
U6
FPQ-216-0.4-03-00/CT909P-Y
1
1
2
3
4
5
CVBS_in_CT909
IPOD-C
100PC185
100PC184
100PC183
100PC182
100PC181
DGND
DGND
R255
0
3
3
3
3
LDON
SSPDON
MOCTLCD_DVDSW
HOMESW
3
VDD
+3.3V
IPOD-C
2
UR1_TX_0
R102
Add
3904
75
DSU R76
R77 10k
SDCMD/MSBC
SDCLK R88
4 SDCMD/MSBC
SDCLK
4
0
C80
R108
75
L19 FB 600R
+3.3V
DGND
C86
C88
+1.8V
EC28
C97
DGND
C96
330p
C95
C94
L26
AGND
VGND MGND
USB_GND
FB 600R
DGND
L27
+3.3V
L28
FB 600R
FB 600R
DGND
SGND
A
R195 10K
R193 10K
R145 10K
R160 10K
R192 10K
10K
10K
10K
10K
10K
R266
R267
R257
R258
R109
AGND
+3.3VA
SWA
SWB
SWC
SWD
SWE
9
9
9
5
IPOD_DETC
BATTERY DETC 1
C203 1nF
Michael Added on 20060714
C
ADD
CP_CLK
CP_DAT
CP_READY
C204 1nF
C205 1nF
C214 1nF
C215 1nF
0
PCK1
R78
R79
R81
0
0
0
STHR
STHL
OEH
R82
0
OEV
R83
R84
R85
R86
0
0
0
0
CKV
STVU
STVD
POL
R75
GNDD
AMP_B
AMP_G
AMP_R
PCK1
STHR
STHL
OEH
OEV
CKV
STVU
STVD
POL
IR
PWM1
DCPWM1
DCPWM2
DCPWM3
DC_FBK2
DC_FBK1
AMP_B
AMP_G
AMP_R
6
6
6
PCK1
STHR
STHL
OEH
OEV
CKV
STVU
STVD
POL
6
6
6
6
6
6
6
6
6
IR
PWM1
DCPWM1
DCPWM2
DCPWM3
DC_FBK2
DC_FBK1
6
6,7,8
6
6,7,8
6,7,8
6,7,8
6
B
GNDD
R89
0
PWM1
R93
R94
R95
R261
R97
0
0
0
0
0
DCPWM1
DCPWM2
DCPWM3
DC_FBK1
DC_FBK2
SF_DO
SF_DIO
SF_CLK
SF_SCN
FA3
FA2
FA1
FA0
TP6
DFTEN
D12
1
R92
SF_DO
SF_DIO
SF_CLK
SF_SCN
CP_DAT
CP_CLK
4148
2
/uPRST
4.7K
EC26
EC27
NC 47u/10V
4
4
4
4
R99
9
9
R98 NC/4.7K
1
D13
NC/4148
NC/10K
C90
Q20
100n
DGND
IR
0
R262
RESET CIRCUIT
YM1
+
ADGND
0/0805
+1.8V
6.04K 1%
75
R129
L25
+3.3V
75
330p
ADGND
FB 600R PCB NC
R106
C93
C89
100n
L22 FB 600R
R107
330p
S_Y
S_C
3.3uH/0805
3.3uH/0805
330p
L23
L24
S_Yin
S_Cin
0
0
DGND
L21
R91
R100
R101
C87
100n
DGND
FB 600R PCB NC
10uF/10V
10uF/10V
Michael Added on 20060714
CVBS_in_CT909
IPOD-C
AGND
5
5
100n
+3.3V
TP5
VADCTP
DGND
NC
R113
10K
PLAY DISC
R76,R77 NC
UR1_RX_0
10K
Q1
+3.3V
R76 NC/10k
0.1uF
R96
5
NF_D5
HOMESW
R90 10k
C116
CVBS_in_CT909 5
NF_D0
NF_D1
NF_D2
NF_D3
LDON
SSPDON
MOCTLCD_DVDSW
3
4
5x1
DIP5-1.25
B
DV33
2 SW2
PWE
SD_DAT3
SD_DAT2
SD_DAT1
SD_DAT0
VGND
AOUT_R
AOUT_R
AOUT_L
AOUT_L
4.7uF 0805/47u/10V
EC25
C75
+3.3V
5
3
K1
K2
K3
K4
10k
R87
SD_DAT3
SD_DAT2
SD_DAT1
SD_DAT0
1.5K/560R
100n
R59
C74
VGND
+3.3VV
47UF10V
NF_D4
4
4
4
4
SD_CD
CVBS
2
NC/3904
TRIN
J4
SD_CD
CVBS
1
5
TRAY SW
UART_I_RX
UART_I_TX
0
R255
SWA
4
TP1
TP1
RX
TX
0
0
0
0
R269
R268
R103
R256
AGND
2
UART_I_RX
100PC180
1nFC179
5
13
UART_I_RX
UART_I_TX
RF_SDEN
RF_SDA
RF_SCK
MIRR
SWE
SWD
SWC
SWB
0
R80
NIM_I2C_SCK
CT909P
33
100PC200
10K
10K
10K
10K
Low Voltage Det
UART_I_TX
0
0
0
0
0
0
R246
R247
0
0
R248
R249
DSU1_RX_0
DSU1_TX_0
RF_SDA
3
100n
DGND R70
R71
R72
R73
K1
K2
K3
K4
PIN HEADER 1X4
DGND
15K/30K
56K/75K
SLPWM 75K/15K
SPDPWM
10K
R60
R61
R62
R63
C76 C77 C78 C79
330P/270p
R68
R69
R67
R66
10K
10K
1
2
3
4
R64
JP2
R65
VDD
UR1_RX_0
UR1_TX_0
SFOCUS
STRACK
SSLED
SMOTOR
SFOCUS
STRACK
SSLED
SMOTOR
3
3
3
3
+3.3V
330P/10n
PIN HEADER 1X4
DGND
220P/200p
DSU1_RX_0
DSU1_TX_0
FODAC
TRDAC
TP3
TP4
33
R58
100PC199
1
2
3
4
33
R57
100PC198
JP1
+ EC23
VGND
R56
DACR
NC/10k R77
VDD
SGND
NF_D0
NF_D1
NF_D2
NF_D3
NF_D4
NF_D5
100n
DACG
100PC197
SBAD
VREF165
3
SGND
C
4.7uF 0805/220u/10V
DACB
100PC196
10u/10V
RFO
MNTR
FEI
TEI
3
+3
3
3
100n
AMP_R
108
107
106
105
104
103
102
101
100
99
98
97
96
95
94
93
92
91
90
89
88
87
86
85
84
83
82
81
80
79
78
77
76
75
74
73
72
71
70
69
68
67
66
65
64
63
62
61
60
59
58
57
56
55
100PC195
EC24
Low Voltage Det 1
RFO C73 680p
MNTR
FEI
TEI
RFENV RFENV
TP2
SBAD
+3.3V
3
MIRR
Low Voltage Det
RFO
L18 FB 600R
+3.3VS
C72
100n
VGND
HIV_R
HIV_VSS5
VD_AVSS3
B
VD_AVDD3
G
VD_AVSS3
R
VD_AVDD3
CVBS
VD_AVSS3
FSADJ
VREF
AAVSS
ADAC2R
ADAC1L
AAVSS
AMID
AAVSS
AAVDD3
GPA[20]/FA[20]
GPA[21]/FA[21]
GPA[22]/FOE_N
GPA[23]/FWE_N
GPA[24]/B[0]/FD[0]
GPA[25]/B[1]/FD[1]
GPA[26]/B[2]/FD[2]
GPA[27]/B[3]/FD[3]
GPA[28]/B[4]/FD[4]
GPA[29]/B[5]/FD[5]
GPA[30]/B[6]/FD[6]
GPA[31]/B[7]/FD[7]
GPE[0]/SPDIF
GPE[1]/ACLK
GPE[2]/PCMWS
GPE[3]/PCMCLK
GPE[4]/PCM SD[2]
GPE[5]/PCM SD[1]
GPE[6]/PCM SD[0]
GPE[7]/PCM SD
GPD[6]/CPH1/PCLK
GPD[7]/CPH2(R0)/STHR/PWM2
GPD[8]/CPH3(R1)/STVU/DCPWM3
GPD[12]/INV(HME)
GPD[13]/STHR
GPD[0]/STHL
GPD[1]/OEH(LP)/PDE
GPD[15]/TC_GPO1
GPD[5]/OEV/TC_GPO0
VDD3
GPD[4]/CLKV/PVS
GPD[14]/STVU
GPD[3]/STVD
GPD[2]/POL/PHS
/uPRST
3
XTALI
XTALO
3
RF_SCK
C92
RF_SDEN
100n
MIRR
VDD3
MA[10]
MA[0]
MA[1]
MA[2]
MA[3]
SV_AVDD3
RFIN
LE
FE
TE
RFENV
FS
SRVM
FODAC
TRDAC
SV_AVSS3
GPF[0]/NF_D[0]
GPF[1]/NF_D[1]
GPF[2]/NF_D[2]
GPF[3]/NF_D[3]
GPF[4]/NF_D[4]
GPF[5]/NF_D[5]
GPF[6]/NF_D[6]
GPF[7]/NF_D[7]
GPB[0]/SLPWM/NIMDATA
GPB[1]/SPDPWM/NIMPWM
VDD18
GPB[2]/SDEN/NIMVLD
GPB[3]/SDATA
GPB[4]/SCLK/NIMCLK
GPB[5]/MIRR/NIMSYN
GPF[8]/NF_ALE
GPF[9]/NF_CLE
GPF[10]/NF_REN
GPF[11]/NF_WEN
GPF[12]/NF_WPN
GPF[13]/NF_BSY
GPF[14]/NF_CE[0]
GPF[15]/NF_CE[1]
GPG[0]/NIMSYN/NF_CE[2]/UR1_RX/TRAYPWM
GPG[1]/NIMVLD/NF_CE[3]/UR1_TX/SMBPWM
GPG[2]/NIMCLK/NF_CE[4]/DSU1_RX/UR2_RX
GPG[3]/NIMDATA/NF_CE[5]/DSU1_TX/UR2_TX
GPG[4]/NIMPWM/drvvbus
VDD3
GPC[15]/MSINS_N
GPC[14]/WP
GPC[13]/SDCD_N
GPC[12]/PWE_N
GPC[11]/SD_DAT3
GPC[10]/SD_DAT2
GPC[9]/SD_DAT1
GPC[8]/SD_DAT0/DSU1_RX/UR1_RX
EC29
RF_SCK
163
164
165
166
167
168
169
170
171
172
173
174
175
176
177
178
179
180
181
182
183
184
185
186
187
188
189
190
191
192
193
194
195
196
197
198
199
200
201
202
203
204
205
206
207
208
209
210
211
212
213
214
215
216
47u/10V
47u/10V
+
RF_SDEN
TP1
C98
5
100n
1,5
SWB
C85
5
SWC
33p
SWA
GPC[7]/SDCMD/MSBC/UR1_TX
GPC[6]/SDCLK/DSU1_TX
VSSA
VCCA3
TPAD
REFBYPASS
RMIDBYPASS
CVBS_Y
CVBS_C
VSSAX
LPFILTER
VCCAX18
PLL2_VSS3
PLL2_VLF
PLL_VDD3
PLL1_VLF
PLL1_VSS3
VBUS
ID
USB_AVDD3
DN
DP
USB_AVSS3
RREFEXT
USB_AVSS18
USB_AVDD18
VDD18
XTALI
XTALO
CLK12XI
CLK12XO
DFTEN
RESET_N
IR
GPC[5]/KEY_DET1/UR2_RX
GPC[4]/D_LATCH1/PWE/UR2_TX
GPC[3]/D_LATCH0
GPC[2]/KS_CLK
GPC[1]/KS_DATA
GPC[0]/KEY_DET0
GPA[0]/SF_CSN/FA[0]/UR1_RX/DSU2_RX
GPA[1]/SF_CLK/FA[1]/UR1_TX/DSU2_TX
GPA[2]/SF_DIO/FA[2]/DSU1_RX/UR2_RX
GPA[3]/SF_DO/FA[3]/DSU1_TX/UR2_TX
VSS
DCFBK3
DCFBK2
DCFBK1
DCPWM3
DCPWM2
DCPWM1
GPD[11]/PWM3
GPD[10]/PWM2
GPD[9]/PWM1/TC_GPO2
SWB
EC22
+
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
SWC
+3.3VA
L16 FB 600R
+3.3V
FB 600R
C71
4.7uF 0805/10u/10V
+
+3.3VSTB
SWA
C91
5
100n
SWE
100n
+3.3VSTB
5
MBA[1]/MCS[1]_N/GPH[1]
MBA[0]
MCS[0]_N
MRAS_N
MCAS_N
MWE_N
VDD18
MA[4]
MA[5]
MA[6]
MA[7]
MA[8]
MA[9]
MA[11]/MCS[0]_N/GPH[0]
MA[12]/MCS[1]_N
MCLK
VSS
MD[8]
MD[9]
MD[10]
MD[11]
MD[12]
MD[13]
MD[14]
MD[15]
VDD3
MDQM
MD[7]
MD[6]
MD[5]
MD[4]
MD[3]
MD[2]
MD[1]
MD[0]
GPA[4]/R[0]/FA[4]
GPA[5]/R[1]/FA[5]
GPA[6]/R[2]/FA[6]
GPA[7]/R[3]/FA[7]
GPA[8]/R[4]/FA[8]
GPA[9]/R[5]/FA[9]
GPA[10]/R[6]/FA[10]
GPA[11]/R[7]/FA[11]
GPA[12]/G[0]/FA[12]
GPA[13]/G[1]/FA[13]
GPA[14]/G[2]/FA[14]
GPA[15]/G[3]/FA[15]
GPA[16]/G[4]/FA[16]
GPA[17]/G[5]/FA[17]
GPA[18]/G[6]/FA[18]
GPA[19]/G[7]/FA[19]
HIV_VDD5
HIV_B
HIV_G
SWE
SWD
100n C115
100n C82
100n C83
100n C84
SWD
L17
C70
27M
R111 1M
C99
C100
27p
27p
C206
100P
GNDD
DGND USB_GND
DGND
CRYSTAL
GND
A
1
0
ON
ON
2
MODE
X SYSTEM MODE
OFF DSU(C/R)
ON
DSU(SPI)
3 FLASH
ON
OFF
P
S
SWA
SWC
SWB
CVBS_in_CT909
SWA
5
SWC
1,5
SWB
5
CVBS_in_CT909 5
Title
Size
D
MAIN BOARD
Document Number
5
4
3
2
DCP851&951
Thursday, December 06, 2007
Date:
1
Sheet
2
Rev
Ver 1.0
of
9
2
3
4
5
1
L12
OPU5V
RFVCC
R23
C27
0
100n
FB 600R
+ EC15
100u/10V
RFVCC
L13
+5V
J3
D
SGND
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
FOCUS+
FOCUSTRACKTRACK+
DVD-B
DVD-C
CD/DVD
RF
DVD-D
DVD-A
CD-F
FB 600R
EC16
+
C28
C29
100u/10V
100n
100n
C30
680p
RFO
CD-E
VR_CD
VR_DVD
CDLD
DVDMDI
DVDLD
C39
C40
Bottom
100n
100n
RFO
2
RF_SDEN
RF_SDA
RF_SCK
2
2
2
MNTR
FEI
TEI
SBAD
2
2
2
2
MIRR
2
U3
VREF25/21
FPC/CON24T
D
SGND
RF
C32
680p
C34
680p
C36
680p
C37
680p
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
C38
100p
DVD-D
DVD-C
DVD-B
DVD-A
CD-F
CD-E
1200X DM520
VREF25/21
SGND
R25 0
DVDMDI
LDON
LDON
2
+ EC17
C45
C46
10u/10V
100n
RFAC
VPA
AIP
AIN
A2
B2
C2
D2
CP
CN
D
C
B
A
CD-F
CD-E
VPB
VC
VNB
DVDLD
CDLD
DVDPD
CDPD
LDON
CT901A
FOFO+
TR+
TRC
D
CD/DVD SW
RF
A
B
F
GND
Vref
VCC
E
NC
CD_VR
DVD_VR
CD_LD
MD
HFM
NC
DVD_LD
GND
BYP
DIN
DIP
FNP
FNN
VNA
RX
SDEN
SDATA
SCLK
V33
MNTR
FE
TE
PI
V165
PIO
MIN
MLPF
DB
MB
MP
DFT
MIRR
48
47
46
45
44
43
42
41
40
39
38
37
36
35
34
33
32
31
30
29
28
27
26
25
C31
100n
C33
C35
100n
100n
RFVCC
RF_SDEN
RF_SDA
RF_SCK
R24
+3.3VS
3.3K
MNTR
FEI
TEI
SBAD
VREF165
C41
C42
C43
C44
150p
1000p
2200p
100n
RFVCC
MIRR
CT901A
100n
R26
C47
12K/1%
100n
+ EC18
10u/10V
C48
100n
+ EC19
C49
C50
1000p 680p
10u/10V
C51
C52
1500p 330p
C
C
SGND
SGND
SGND
RFVCC
HA1
HOMESW
2
+ EC20
R27
10
4x1
R28
1
0
RFVCC
VR_CD
C53
2
SLED+
SLED-
L14
DVDLD
1000p
1
RFVCC
CD/DVD
R31
+ EC21
10
3
R33
0/1K
1
Q17
1 R32
CD_DVDSW
10K
3904
R34
100K
CD_DVDSW
2
Hi : DVD
Lo : CD
SGND
2
L15
CDLD
Q19
SSN00206M
C54
2
B
R30
10K
VR_DVD
3
1
100K
SGND
100u/10V
Q18
8550
R29
3
10uH/0805
2
HA2
Q16
SSN00206M
2
Q15
8550
2x1
2
1
100u/10V
3
SGND
3
DCMO+
DCMOHOMESW
1
2
3
4
SGND
B
1000p
Place Close
10uH/0805
SGND
+5V
R35
2
SFOCUS
2
SSLED
SFOCUS
SSLED
C55
R40
24K
R43
20K
SLEDSLED+
FOCUSFOCUS+
220P
1
2
3
4
5
6
7
10K
R37
C58
8
9
10
11
12
13
14
5VM
4700P
R49
R51
1
1
EC61
100u/10V
+
C59
12K
VINFC
CFCERR1
CFCERR2
VINSL+
VINSLVOSL
VNFFC
VCC
PVCC1
PGND
VOSLVOSL+
VOFCVOFC+
R36
+5V
U4
STBY
BIAS
VINTK
CTKERR1
CTKERR2
VINLD
PREGND
28
27
26
25
24
23
22
PVCC2
VNFTK
PGND
VOLDVOLD+
VOTKVOTK+
21
20
19
18
17
16
15
SSPDON
33
R38
STRACK
R39
10K
VREF165
C56
220P
SMOTOR
SSPDON
2
STRACK
2
SMOTOR
2
1
2
3
4
5VM
DCMODCMO+
AT5654
SOP
100n
C61
100n
100n
AO
AA+
V-
V+
BO
BB+
UTC3308
R50
R52
C60
C57
U5
1
1
8
7
6
5
100n
4.7K
R42
1M
R45
56
R48
R41
1K
MOCTL-
R44
R46
10K
10K
DCMO+
DCMO-
MOCTL-
2
R47
56
TRACKSGND
TRACK+
22K
R54
R53
22K
47K
A
A
SGND
MGND
MGND
MGND
Title
Size
C
5
4
3
2
Date:
MAIN BOARD
Document Number
DCP851&951
Thursday, December 06, 2007
1
Sheet
3
Rev
Ver 1.0
of
9
2
MD[0..15]
2
MA[0..12]
D
U7
2
2
2
2
/CAS
/RAS
/CS0
/WE
2
MCLK
MBA1
MBA0
/CAS
/RAS
/CS0R118
/WE
0
/CS
MCLK
R121
+3.3V_MD
35
22
34
33
32
31
30
29
26
25
24
23
A11
A10
A9
A8
A7
A6
A5
A4
A3
A2
A1
A0
21
20
BS1
BS0
NC/0
17
18
19
16
37
38
CAS
RAS
CS
WE
CKE
CLK
1
14
27
3
9
43
49
VCC
VCC
VCC
VCCQ
VCCQ
VCCQ
VCCQ
W986416DH
(04_29) modify OK
MBA1
MBA0
1
MD[0..15]
MA[0..12]
MA12
MA11
MA10
MA9
MA8
MA7
MA6
MA5
MA4
MA3
MA2
MA1
MA0
2
2
2
3
4
5
DQ15
DQ14
DQ13
DQ12
DQ11
DQ10
DQ9
DQ8
DQ7
DQ6
DQ5
DQ4
DQ3
DQ2
DQ1
DQ0
53
51
50
48
47
45
44
42
13
11
10
8
7
5
4
2
NC
NC
40
36
UDQM
LDQM
39
15
VSS
VSS
VSS
VSSQ
VSSQ
VSSQ
VSSQ
28
41
54
6
12
46
52
D
+3.3V
R116
R119
0
MDQM
MA12
2
2
2
SF_SCN
SF_DO
10K
SF_CSN
SF_DO
L29 FB 600R
R115
C102
2,3,4,7
10K
MDQM
+3.3V
R117
SF_1
SF_2
SF_3
SF_4
1
2
3
4
10K 100n
H
U8
/CS
VCC
DO /HOLD
/WP
CLK
VSS
DIO
8
7
6
5
SF_8
SF_7
SF_6
SF_5
+3.3V
+
EC30
10u/10V
DGND
R120
MX25L8005MC-15G
C103
8 PIN SOIC Package
208Miles
NC
DGND
BJ56L64164
DGND
MD15
MD14
MD13
MD12
MD11
MD10
MD9
MD8
MD7
MD6
MD5
MD4
MD3
MD2
MD1
MD0
SF_CLK
SF_CLK
SF_DIO
SF_DIO
0
2
2
DGND
DGND
R21
0 0805
+3.3V_SD
Q13
L21 NC/ FB 600R NC/2307
3
2
C
+3.3V
C79
EC19
100n
47u/16V
1
R16
NC/4.7K
C
R20
+3.3V_MD
[2]
+3.3V_MD
PWE#
NC1K
L30 FB 600R
EC10
NC/10u/16V
+3.3V
100u/10V
100n
100n
100n
100n
100n
100n
100n
DGND
DGND
CON1
SDMEMORYCARD
KA-1A
100n
DGND
13
DGND
C105 C106 C107 C108 C109 C110 C111
G
EACH POWER PIN -- A BYPASS CAPACITOR
D3
CMD
VSS
VDD
CLK
VSS
D0
D1
D2
B
1
2
3
4
5
6
7
8
9
0
0
R123 0
R145
R126
0
R127
R128
G
10
11
C112
15
G
INS_SW
WP_SW
20pF
0
SD_DAT3
SDCMD/MSBC
SDCLK
R125
10k
SD_DAT0
SD_DAT1
SD_DAT2
B
0
SD_CD
0.1uF
14
+3.3V
R122
C209
EC31
12
+
G
C104
2
SDCLK
2
SD_DAT0
2
SD_DAT1
2
SD_DAT2
2
SD_DAT3
2 SDCMD/MSBC
2
SD_CD
SDCLK
SD_DAT0
SD_DAT1
SD_DAT2
SD_DAT3
SDCMD/MSBC
SDCD#
DV33
R130
R131
R132
R133
R134
R135
10k
10k
10k
10k
10k
10k
CB4
0.1uF
A
A
Title
Size
C
Date:
5
4
3
2
MAIN BOARD
Document Number
DCP851&951
Thursday, December 06, 2007
1
Sheet
4
R ev
Ver 1.0
of
9
2
3
4
5
R136
1
43K
L31
0
C117
180p
10uF/10V
NC
1800pF
1
NJM4558-SOP-8
EC33
0
DVD_L
C124
NC
1800pF
2
UART_I_RX
2
4
5
U9B
EC35
7
NJM4558-SOP-8
EC35
1 B E3
2N3906
+9VIN
UART_I_TX
6
10uF/10V
R157 0R
FB600R L36
EC36
22uF/25V
VDD
+Vcc
+
1
1
2
3
4
5
A_L_SPEAKER
R_HP_IN
C125
A_R_SPEAKER
VJ1
L_HP_IN
A_R_SPEAKER
AV-OUT-R
R158
10uF/10V
+
R162
C2
C2
1 B E3
2N3904
VER
R159
+
10uF/10V
2
R156
5.1K
10K
8
R155
+
2
EC34
DVD_R
180pF
-
SWE
AU_R_OUT
0
NC
IPOD-C
NC
43K
R152
2
5.6K
AC
R151
SWB
5
D
820p
NC
1,2
4
3
C122
AV-OUT-L
7
R144 0
FB2K2
R150
2
SWC
R161
UART_I_RX
AV-OUT-R L35
6
2
CVBS_in_CT909 2
UART_I_TX
AV-OUT-L
6
7
2
100K
AOUT_L
SWD
SWE
SWA
JACK1
R149
2
R141
10uF/10V
FB2K2
L34
NC
AOUT_R
0R
100K
8.4V_CHARGE 1
IPOD-C
2
100K
C123
CVBS_in_CT909
R140
10uF/10V
R148
R154
SWD
SWB
EC33
+Vcc
VGND
SWC
CVBS_O
4
3
R153
0
SWA
AV/OUT-JACK
R137 0
FB2K2
+
C121
R146
8.4V_CHARGE
L32
R147
VGND
R143
2
+
C120
U9A
R139
5.1K
10K
R138
8
EC32
AU_L_OUT
+
75
D
DVD_CVBS
1.8uH
C119
100p
R142
AV-OUT-L
22p
-
C118
L33
CVBS
2
180pF
820p
VOLUME 10K
5.6K
R163 51K
1
2
3
4
5
R164
AC
100K
VER
+EC37
C126
R165
C127
0.1uF
56K
0.1uF
10uF/10V
C
C
R166
10K
EC38 47uF/10V
+
2
4
6
8
RN1
0
VDD
1
3
5
7
VDD
X2
X1
X
X0
X3
A
B
10uF/10V
0.1uF
16
15
14
13
12
11
10
9
EC43
SWD
SWE
EC44
10uF/10V
AV_IN_L
10uF/10V
+9VIN
DVD_L
Q23
1
10uF/10V
1
2
3
4
5
6
7
SWC
SWA
VDD
IN1
OUT1 CT1
IN2
CT4
OUT2 OUT4
CT2
IN4
CT3 OUT3
VSS
IN3
14
13
12
11
10
9
8
EC53
C134
DVD_CVBS
10uF/10V
CVBS_In
1
1
MUTE
820P
U12
L_HP_IN
EC56
10uF/16V R179
100K
7
8
R_HP_IN EC58
10uF/16V R182
100K
6
VDD
5
4
C140
R183
R184
0.1uF
CVBS_OUT
J5
2
Q24
13
A
3904
R187
R188
10K
R189
75
C141
+
EC60
100uF/10V
10K
75
1
2
3
CVBS_O
4
5
6
7
8
9
10
11
12
12PINCON
10K
820P
1
EC57
3
EC59
100uF/10V
L41
FB2K2
L
100uF/10V
L42
FB2K2
R
VER2
APA2822
C138
0.1uF
C139
0.1uF
R185
R186
4.7R
4.7R
200
R178
200
R180
200
R181
200
R
L
C142
8.4V_CHARGE
0.1u
A
J6
IPOD-Y
IPOD-C
IPOD-CVBS
1
UART_I_RX
UART_I_TX
IPOD_DETC
R190
0
IPOD/PI_O_L
R191
0
IPOD/PI_O_R
IPOD_DETC
2
1
2
2
3
3
4
4
CON20
SPK_L
C144
SPK_R
C145
33uF
33uF
Title
Size
C
5
R177
11
10
9
earphone
0.1u C147
0
10K
earphone
11
10
9
100uF/10V
0.1u C146
0
0
C135
5
4
8
1
0
R176
1
2
3
6
7
0
0
CVBS_in_CT909
0.1u C143
1
1
820P
VER1
+ EC54
+
0
EPORT
IPOD
C133
0.1uF
+
1
10uF/10V
2
SWE
0
SWA
+
EC49
100uF/16V
+EC51
+
SWD
1
0
0.1uF
+
SWB
0
SWC
DVD
820P
VDD
10uF/10V
EC55 10uF/10V
C131 C132
100P
B
CVBS_OUT
SWC
SWB
EC52
C130
5
4
8
10uF/10V
EC50
6
7
10k
EC48
R172
IPOD-CVBS
IPOD-Y
10uF/10V
75
EC47
6
7
0
10k
B
R175
100K
R169
FB2K2
R171
+
JACK2
2
R174 2R(0805)
EC46
47uF/25V
R173 2R(0805)
IPOD/PI_O_L
10uF/10V
AV_IN_R
L40
SSP0403STR
VCC9
3
D14
IN4148
4066
FB2K2
R170
AU_L_OUT
EC45
U11
CVBS_In L39
3
4052
Y0
Y2
Y
Y3
Y1
INH
VEE
VSS
AV/OUT-JACK
R168 0
0.1u C137
10uF/10V
U10
+EC40
FB2K2
1
2
3
6
7
1
2
3
4
5
6
7
8
AU_R_OUT
DVD_R
EC42
C129
2
AV_IN_R
EC39 10uF/10V
EC41
10uF/10V
AV_IN_L L38
5
1
3
5
7
IPOD/PI_O_R
L37
100Kx4
100Kx4
1
RN2
0.1u C136
10K
4
2
4
6
8
0.1uF
R167
C128
4
3
2
Date:
MAIN BOARD
Document Number
DCP851&951
Thursday, December 06, 2007
1
Sheet
5
Rev
Ver 1.0
of
9
4
5
3
2
1
J8
VROUT
VGOUT
VBOUT
JP3
PCK1
1
2
3
4
STHR
STHL
OEH
OEV
CKV
STVU
STVD
D
2
2,7,8
2
2,7,8
2,7,8
2,7,8
2
C160 0.1uF
1
22
VSW
1
C163 0.1uF
22
1
3
1
C
R201
2
C161
1uF
C164
1
4.7k
+9VIN
DN3
VGL
D
J9
Q26
2N3906
1
2
3
4
5
6
7
8
9
10
11
+9VIN
D18
12V
2
C167 0.1uF
22
1
VGL
2
1uF
DN2 SS214U
IR
PWM1
DCPWM1
DCPWM2
DCPWM3
DC_FBK2
DC_FBK1
3
3
11
IR
PWM1
DCPWM1
DCPWM2
DCPWM3
DC_FBK2
DC_FBK1
POL
SS214U DN1
C162
IR
+5VD
PWM1
DCPWM2
DCPWM3
DC_FBK2
VGL
VGH
47uF/16V PCB 0805 10UF
2
2
2
2
2
2
2
2
2
2
1
PCK1
STHR
STHL
OEH
OEV
CKV
STVU
STVD
POL
PIN HEADER 1X4
2
2
2
2
1
PCK1
STHR
STHL
OEH
OEV
CKV
STVU
STVD
POL
AMP_B
AMP_G
AMP_R
+
AMP_B
AMP_G
AMP_R
1
2
3
4
5
6
7
8
9
10
11
1
3
C
SS214U
R209
C175
+
1
2
2
1uF
VGH
Q27
2N3904
1
R210
1k
1
1k
VGH
2
2
3
D19
16V
C176
1
47uF/16V PCB 0805 10F
2
AMP_R
2
AMP_G
2
AMP_B
C172 0/0805
VROUT
C173 0/0805
VGOUT
C174 0/0805
VBOUT
B
B
0R/0805
C177
10u/10V/0805
VSW
100uH/COIL
1
L44
D20
BAT54C
3
Q25
1
DCPWM1
1K(4.7K)
R194
13K
DC_FBK1
2N3904/SOT23
2
R200
1.8K
2
R197
3
2
C155 10n
2
SW_DC
10u/10V C154
R193
100nC178
+5VD
L46 FB 600R PCB NC
A
A
Title
Size
B
5
4
3
2
Date:
MAIN BOARD
Document Number
DCP851&951
Thursday, December 06, 2007
Sheet
1
5
Rev
Ver 1.0
of
9
4
5
3
2
1
VCC
D
D
PPL4
FB 0805
2
VCC
10K
10K
Vcc
PU2
C
2 CP_CLK
7
I2C_SCL
2 CP_DAT
15
I2C_SDA
8
I2C_ADDR0
9
I2C_ADDR1
10
I2C_ADDR2
18
SPI_nSS
19
SPI_SIMO
20
ROSC
XIN
PR27
PR28
10K
10K
10K
PR7
100K I%
PR1
10K
PD1
IN4148
RESET
0.1uF
17
RESET Circuit
PC9
2
C
12pF
VCC
Closed to
IC's pin
3
PC10 12pF
nRESET
SPI_SOMI
SPI_UCLK CLOCK_ENAB
11
CP_READY
38
PR18
RESET
10K
4
MODE0
12
MODE1
13
MODE2
16
B
Vss
CLOCK_OUT
PC5
PCE3
10uF/6.3V
PY1
39
PR26
PCE1
10uF/16V
32.768KHz
21
32
B
+
+
XOUT
2 CP_READY
PC8
0.1uF
1
10K
PC7
1000pF
40
PR17
1
PR9
Vcc
PR8
CP For iPod
PR23
PR24
PR25
10K
10K
10K
A
A
Title
Size
B
5
4
3
2
Date:
MAIN BOARD
Document Number
DCP851&951
Thursday, December 06, 2007
Sheet
1
9
Rev
Ver 1.0
of
9
POL
D
+5VD
TR3
10K
TR4
10K
TC2
POL
3
+
2
-
VSW
DCPWM2
DCPWM3
DC_FBK2
PWM1
2,6,7
2,6,7
2,6,7
2,6,7
VSW
7
TU1A
UTC3308
1
TR1
22K
5
+
6
-
VCOMA
TU1B
UTC3308
7
TR5
22K
VGL
VOL+-
TMC3K-50K
TC3
10uF/16V
D
3
8
TC4
100n
2
TVR1
2
4
10uF/16V
DCPWM2
DCPWM3
DC_FBK2
PWM1
TC1
100n
TR2
10K
1
PIN HEADER 1X4
1
+5VD
TR7
15K/18K
VGL
1
3
STHR
STHL
OEH
OEV
CKV
STVU
STVD
2
+5VD
4
1
2
3
4
5
6
7
8
9
10
11
47uF/16V
1
2
3
4
VROUT
VGOUT
VBOUT
3
TJ1
PCK1
TR35 100R
TR6
1K
TC37
TJP1
8
4
5
TJ2
1
2
3
4
5
6
7
8
9
10
11
+9VIN
IR
+5VD
PWM1
DCPWM2
DCPWM3
DC_FBK2
VGL
VGH
C
TR9
PCK1
TC8
NC/22p
AU7A_J1
0
26 1
TC9
NC/22p
GNDD
GNDD
+5VD
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
VBOUT
VGOUT
VROUT
VPNLA
TL1
+5VD
TC15
10uF/16V
P_CPH1
100n TC17
100n TC16
FB 600R
P_STHR
P_STHL
P_OEH
P_LRC
NC/10u/16V/1206
TR19
10
IR
P_LRC
P_UDC
TJ3
FPC CONN 26P/B
钡Α
Board edge
GNDD
A
Size
B
Date:
4
B
Standard 7" panel:
VGH=+15V/VGL=-10V
Title
5
AVSS
AVDD
B
G
R
GND1
VCC1
CPH1
CPH2
CPH3
STHR
STHL
OEH
MOD
L/R
VCOM1
VCOM0
OEV
U/D
CKV
STVL
STVR
VGH
VGL
VCC0
GND0
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
GNDD
TC24
100pF
A
TC20
TC23
100n TC22
TR15
VGH
VGL
VPNLA
NC/10u/16V/1206
TR18
IR
TR17
TR16
10
TIR1
NC
+5VD
10K
P_CPH01
NC
TR14
VPNLA
10K
PCK1
P_OEV
P_UDC
P_CLKV
P_STVU
P_STVD
100n TC21
P_STHR
P_STHL
P_OEH
P_OEV
P_CLKV
P_STVU
P_STVD
1
2
3
B
STHR
STHL
OEH
OEV
CKV
STVU
STVD
VCOMA
GNDD
C
VGND
3
2
TFT BOARD
Document Number
DCP851&951
Thursday, December 06, 2007
Sheet
1
5
Rev
Ver 1.0
of
9
5
3
4
2
1
D
D
100uH
2
10/0805
2
AD3
1
AC9
22K
5.6V
16
2
REF1
V-D
15
2.2uF/25V
100R
AR22
AU5
10R
FB2
GND
11
7
TFB
RT
10
8
ATC
CT
9
AR10
AR21
1
SS7707
AR25
AC8
AD2
5.6V
AR8
1
AQ2 3906
2.2K
2
3
AC1
0.1uF
100R
AR6
1K
AR20
AR19
AC7
4.7K
0.1uF
10K
100K
2
2
2
AQ3
3
7.4
AR17
1
2N3904
2
1
100R
2
BL_EN
1
>220
AR16
2N3904
10K
B
2
1
1
AR11
1K
AR12
4K7
AQ4
2
AR14
2
B
1K
2
AR13
1
3.9K /4.7K 1%
2
AR18
1
bright 9.4V
>100
3
2
0.1uF
AR24
2200P
4.7K
10R
2
22K
AC6
1
2
1K
6
5
AR15
470R
1
1
2
AR1
REF2
4
C
910R
1
V-D
12
5
+5V
AR7
2
13
7
6
2
14
B-D
2
3
2
A-D
NC
1
FB1
4
1
2
100K NTC 1%
3
2
4700P
8
1
22K
1
2
AC3
STM4532
1
VCC
HV3
AC33
1
1
2
RT21
1
7V5
REF
1
SS214U
1
2
AR4
3
3906
AD4
1
5
2
0.1uF
1
2
2
1
AQ1
2
2
2.2uF
AQ11
6
3
4
2
10K
AR2
330K
C
AC4
0.1uF
AU1
1
AR5
39K/33K
5
AR23
AC2
2
1
1
1
AR9
4
2
10uF/16V(A)
AR26
1
0.1uF
1
AR3
470
7
6
HV+
7
2
AE5
2
3
TRANSFORMER DC-AC CI-8.5 (SKT)
1
2
1
AC5
8
2
100uF/16V/SMD
AT1
STM4532
1
1
0.1uF
1
AR58
1
AE4
2
+5V
AU4
AC10
2
AL1
1
1
+9V
A
A
Title
Size
C
Date:
5
4
3
2
TFT BOARD
Document Number
DCP851&951
Thursday, December 06, 2007
1
Sheet
5
Rev
Ver 1.0
of
9
5
3
4
2
1
D
D
TP1
TPJ1
RFO
KS1
C
KS3
KS2
TP2
Next
RFO
PLAY/PAUSE
KEY1
KEY2
KS5
TP3
Source
KEY3
RFO
Down
KS7
Right
1
2
3
4
5
5x1
DIP5-1.25
C
KS6
PRE
RFO
TP2
KEY1
KEY2
KEY3
KEY4
UP
KS4
K1
K2
K3
K4
KS8
ENTER
KS9
KEY4
Left
TP4
RFO
B
B
KEY3
4:3/16:9
KEY1
MENU
KEY2
POWER ON/OFF
114PIN
113PIN
0
0
SW1
A
A
Title
SW2
Size
A
5
4
3
Date:
TFT&KEY BOARD
Document Number
DCP851&951
Thursday, December 06, 2007
2
Rev
Ver 1.0
Sheet
5
1
of
9
5
3
4
R1
D
C
U1
GND
A/V GND
Line out - R
Line out - L
Line in - R
Line in - L
N.C
VIDEO OUT
S-VEDIO C
S-VEDIO Y
Serial GND-D
Serial TXD
Serial RXD
N.C
GND
USB GND
N.C
3V3 POWER OUT
12V POWER IN
12V POWER IN
UART ENABLE
DATA TPA5V USB POWER
DATA TPA+
USB DATA LDATA TPBUSB DATA L+
DATA TPB+
INPUT GND
INPUT GND
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
R4
R5
2
10K
R2
10K
R3
75
D
J1
22K
AU-R
AU-L
CVBS
TX
RX
IPOD_DET
22K
+5V(+12V)
R6
R7
560K
R8
R9
75K
R10
75K
R11
49.9K1%
B
C
NC
0R
49.9K1%
B
Title
Size
A
Date:
4
1
2
3
4
5
6
7
8
9
R12
A
5
1
3
A
IPOD CONNECT BOARD
Document Number
DCP851&951
Thursday, December 06, 2007
2
Rev
Ver 1.0
Sheet
5
of
1
9
DCP851&951 MAIN BOARD BOTTOM
DCP851&951 TFT BOARD TOP
DCP851&951 TFT BOARD BOTTOM
DCP851&951 KEY BOARD TOP
DCP851&951 KEY BOARD BOTTOM
DCP851&951 IPOD BOARD TOP
DCP851&951 IPOD BOARD BOTTOM
DCP851&951 BATTERY BOARD TOP
DCP851&951 BATTERY BOARD BOTTOM
8.0 SERVICE PART LIST
Electrical Part List:
CTN
Service 12NC
Service Description
Photo
Pos.
No.
DCP851/37
DCP851/98
996510019520
996510015768
MAIN PCBA
100
DCP851/37
DCP851/98
996510015530
996510015791
TFT DRIVER PCBA
110
DCP851/ALL
996510015425
KEY PCBA
120
DCP851/37
DCP851/98
996510019521
996510015426
IPOD PCBA / CONNECTION PCBA
130
DCP851/ALL
996510015472
BATT PCBA + BATTERY PACK
140
8.0 SERVICE PART LIST
Mechanical Part List:
CTN
Service
12NC
Service Description
Photo
Pos.
No.
DCP851/ALL
996510015531
8.5” LCD PANEL AUO
200
DCP851/ALL
996510007686
DVD LOADER 1200X
210
DCP851/ALL
996510002384
FFC 24PIN 130MM
220
DCP851/ALL
996510015429
HOUSING 4PIN 100MM
230
DCP851/ALL
996510015430
HOUSING 5PIN 150MM
240
DCP851/ALL
996510015431
HOUSING 9PIN 60MM
250
DCP851/ALL
996510015432
HOUSING 11PIN 90MM
260
DCP851/ALL
996510015433
DVD TOP CABINET
300
8.0 SERVICE PART LIST
Mechanical Part List:
CTN
Service
12NC
Service Description
Photo
Pos.
No.
DCP851/ALL
996510015434
SPEAKER GRILL
310
DCP851/ALL
996510015435
DVD BOTTOM CABINET
320
DCP851/ALL
996510015428
CIRCLE RING SILVER
330
DCP851/ALL
996510015424
CD DOOR
340
DCP851/ALL
996510015439
STAND BLACK
350
DCP851/ALL
996510015440
STAND OPEN KNOB
360
DCP851/ALL
996510015441
STAND HEAD GEAR
370
DCP851/ALL
996510015475
SPRING HOLDER
380
8.0 SERVICE PART LIST
Mechanical Part List:
CTN
Service
12NC
Service Description
Photo
Pos.
No.
DCP851/ALL
996510015442
CHARGE RING WHITE
390
DCP851/ALL
996510015443
DOOR SLIDE SPRING
400
DCP851/ALL
996510015444
DOOR SLIDE COVER
410
DCP851/ALL
996510015445
DOOR OPEN KNOB
420
DCP851/ALL
996510015446
CD DOOR SPRING
430
DCP851/ALL
996510015447
SLIDE CHANNEL 1
440
DCP851/ALL
996510015448
SLIDE CHANNEL 2
450
DCP851/ALL
996510015449
DOCKING SPRING
460
8.0 SERVICE PART LIST
Mechanical Part List:
CTN
Service
12NC
Service Description
Photo
Pos.
No.
DCP851/ALL
996510015450
IPOD DOCKING CABINET
470
DCP851/ALL
996510015451
DOCKING COVER
480
DCP851/ALL
996510015452
IPOD SOCKET CABINET
490
DCP851/ALL
996510015453
SOURCE KEY
500
DCP851/ALL
996510015454
PLAY / PAUSE KEY
510
DCP851/ALL
996510015455
PREVIOUS KEY
520
DCP851/ALL
996510015456
NEXT KEY
530
DCP851/ALL
996510015457
OK BUTTON
540
8.0 SERVICE PART LIST
Mechanical Part List:
CTN
Service
12NC
Service Description
Photo
Pos.
No.
DCP851/ALL
996510015458
NAVIGATION KEY
550
DCP851/ALL
996510015459
PRESS IPOD LOCK PIECE
560
DCP851/ALL
996510015460
PRESS STAND COVER
570
DCP851/ALL
996510015461
PRESS MONITOR
580
DCP851/ALL
996510015462
IPOD LOCK COVER
590
DCP851/ALL
996510015463
IPOD LOCK SPRING
600
DCP851/ALL
996510015464
DOCKING OPEN KNOB
610
DCP851/ALL
996510015465
PRESS STAND KNOB COVER
620
8.0 SERVICE PART LIST
Mechanical Part List:
CTN
Service
12NC
Service Description
Photo
Pos.
No.
DCP851/ALL
996510015466
STAND SPRING
630
DCP851/ALL
996510015467
MONITOR KEY
640
DCP851/ALL
996510015468
NENU KEY
650
DCP851/ALL
996510015469
POWER KEY
660
DCP851/ALL
996510015470
POWER RING
670
8.0 SERVICE PART LIST
Accessories Part List:
Service 12NC
Service Description
996510010991
CAR ADAPTER
996510010992
AC/DC ADAPTER /37 (DCP851/37)
Photo
Pos. No.
010
020
996510010378
AC/DC ADAPTER /98 (DCP851/98)
996510010993
REMOTE CONTROL
030
996510000788
AV CABLE
040
996510010994
IPOD CLASSIC ADAPTER
050
996510010995
IPOD NANO ADAPTER
060
996510010996
IPOD NANO HIGH CLIP
070
8.0 SERVICE PART LIST
996510010997
IPOD TOUCH ADAPTER
080
996510010998
IPOD TOUCH HIGH CLIP
090
9.0 REVISION LIST
Version 1.0 (3141 785 32600)
• Initial release for DCP851/37 (for LatAM) and DCP851/98
Version 1.1 (3141 785 32601)
• Update 12NC of main-board and iPod-board due to quality issue (IPM-30992)