Download K6394 A90 9923 Service Manual - Amp Air
Transcript
TOSHIBA FILE NO. A90-9923 SERVICE MANUAL AIR-CONDITIONER SPLIT TYPE, HEAT PUMP BUILT-IN DUCT TYPE RAV-164BH-PE/164AH-PE RAV-264BH-PE/264AH-PE RAV-264BH-PE/264AH8-PE RAV-364BH-PE/364AH8-PE RAV-464BH-PE/464AH8-PE CEILING TYPE RAV-134CH/CHR-PE/134AH-PE RAV-164CH/CHR-PE/164AH-PE RAV-264CH/CHR-PE/264AH-PE RAV-264CH/CHR-PE/264AH8-PE RAV-364CH/CHR-PE/364AH8-PE RAV-464CH/CHR-PE/464AH8-PE WALL TYPE RAV-134KH/KHR-PE/134AH-PE RAV-164KH/KHR-PE/164AH-PE RAV-264KH/KHR-PE/264AH-PE RAV-264KH/KHR-PE/264AH8-PE CARCASE TYPE RAV-104NH-PE RAV-134NH-PE/134AH-PE RAV-164NH-PE/164AH-PE RAV-264NH-PE/264AH-PE RAV-264NH-PE/264AH8-PE LOW WALL/PAINTED FLOOR TYPE RAV-164SH/SHR-PE/164AH-PE RAV-264SH/SHR-PE/264AH-PE RAV-264SH/SHR-PE/264AH8-PE 2 WAY CASSETTE TYPE RAV-104TUH-PE RAV-134TUH-PE/134AH-PE RAV-164TUH-PE/164AH-PE 4 WAY CASSETTE TYPE RAV-164UH-PE/164AH-PE RAV-264UH-PE/264AH-PE RAV-264UH-PE/264AH8-PE RAV-364UH-PE/364AH8-PE RAV-464UH-PE/464AH8-PE Printed in UK DECEMBER 1999 CONTENTS 1. SPECIFICATIONS 2. CONSTRUCTIONS VIEWS 3. WIRING DIAGRAMS 4. SPECIFICATIONS OF ELECTRICAL PARTS 5. REFRIGERANT PIPING DIAGRAMS 6. PERFORMANCE CHARACTERISTICS 7. EXPLODED VIEWS AND PARTS LISTS 3 21 31 41 56 62 65 SUMMARY The units referred to within this Manual conform with the protection requirements of Directives 89/336/EEC Electromagnetic Compatibility and 73/23/EEC Low Voltage. Operating conditions of units are as follows: OUTDOOR TEMPERATURE -2 to 43ûC (COOL) -10 to 21ûC (HEAT) ROOM TEMPERATURE 18 to 32ûC (COOL) 15 to 29ûC (HEAT) ROOM HUMIDITY LESS THAN 80% (COOL) Note 1: Cooling Capacity is based on the following temperature conditions: Indoor air inlet temperature 27ûC DB, 19ûC WB. Outdoor air inlet temperature 35ûC DB. Note 2: Heating Capacity is based on the following temperature conditions: Indoor air inlet temperature 20ûC DB. Outdoor air inlet temperature 7ûC DB, 6ûC WB. Note 3: For details on Control Circuits, refer to Service Manual A90-9925. Note 4: Metric/Imperial pipe conversion: Diameter (mm) 6.4 9.5 12.7 15.9 19 22 Nominal Diameter (inch) 1/4 3/8 1/2 5/8 3/4 7/8 2 1. SPECIFICATIONS Item Cooling capacity Heating capacity Power source Power consumption Power factor Running current Starting current Operating noise (SPL) Refrigerant Indoor Unit (High, Med, Low) Outdoor Unit Name of Refrigerant Charge Volume Add. Volume (20-30m) Model RAV-164BH-PE kW kW Phase V Hz 4.5 5.0 1 220-240 50 kW % A A dB(A) dB(A) m m 30 kg g/m Larger side size Coupler style Smaller side size Coupler style Standard length Maximum actual pipe length (of one way) Maximum height difference If Indoor Unit higher If Outdoor Unit higher mm Height Width Depth mm mm mm kg Condensate drain pipe diameter INDOOR UNIT Model Appearance colour Dimensions Net weight Heat exchanger type Indoor fan type Air volume Fan motor output External static pressure OUTDOOR UNIT Model Appearance colour Dimensions Standard Max. motor Height Width Depth Net weight Heat exchanger type Outdoor fan type Air flow volume Fan motor output Compressor mm m m mm m3/h W mmAq mmAq mm mm mm kg m3/h W Model Output kW Protective device 15 30 ¿32.5 (ID) RAV-164BH-PE Black (zinc galvanized steel & thermal insulator) 345 770 875 39 Finned tube Multi-blade fan 840 60 4 10 RAV-164AH-PE Bronze white (Munsell 6Y7.5/1) 740 880 310 61 Finned tube Propeller fan 2,700 39 PG350X3F-4LS 1.5 High pressure switch, fuse, crankcase heater, inner overload relay, bi-metal thermostat RBC-RK162BE-PE Long-life filter kit Dimensions HEATING 2.2 89 10.7 60 42/39/36 50 R407C 1.2 35 Capillary tube & Expansion valve ¿12.7 Flare ¿6.4 Flare 7.5 Refrigerant control Interconnection pipe COOLING 2.2 90 10.6 Height Width Depth Net weight Air filter mm mm mm kg 80 700 285 8 Washable Specifications are subject to change without notice 3 1. SPECIFICATIONS Item Model RAV-264BH-PE Cooling capacity Heating capacity kW kW Phase V Hz 7.1 7.9 1 220-240 50 Power source Power consumption Power factor Running current Starting current Operating noise (SPL) Refrigerant Indoor Unit (High, Med, Low) Outdoor Unit Name of Refrigerant Charge Volume Add. Volume (20-30m) kW % A A dB(A) dB(A) Dimensions Net weight Heat exchanger type Indoor fan type Air volume Fan motor output External static pressure OUTDOOR UNIT Model Appearance colour Dimensions 30 30 15 30 ¿32.5 (ID) RAV-264BH-PE Black (zinc galvanized steel & thermal insulator) 345 1,070 875 53 Finned tube Multi-blade fan 1,140 100 4 10 RAV-264AH-PE Bronze white (Munsell 6Y7.5/1) 790 880 310 80 Finned tube Propeller fan 3,000 63 PG460X3F-4MS 2.2 High pressure switch, fuse, crankcase heater, inner overload relay, bi-metal thermostat 15 30 ¿32.5 (ID) RAV-264BH-PE Black (zinc galvanized steel & thermal insulator) 345 1,070 875 53 Finned tube Multi-blade fan 1,140 100 4 10 RAV-264AH8-PE Bronze white (Munsell 6Y7.5/1) 790 880 310 80 Finned tube Propeller fan 3,000 63 YG460X3F-MS 2.2 High pressure switch, fuse, crankcase heater, over current relay, bi-metal thermostat, reverse phase protector RBC-RK262BE-PE RBC-RK262BE-PE 80 1000 285 10 Washable 80 1000 285 10 Washable mm mm mm kg Net weight Heat exchanger type Outdoor fan type Air flow volume Fan motor output Compressor mm m m mm m3/h W mmAq mmAq mm mm mm kg m3/h W Model Output kW Protective device Long-life filter kit Dimensions Height Width Depth Net weight Air filter HEATING 2.95 85 5.0 m Height Width Depth Height Width Depth COOLING 2.9 85 4.9 m kg g/m mm Standard Max. motor HEATING 2.95 90 14.2 25 43/40/37 53 R407C 1.9 35 Capillary tube & Expansion valve ¿15.9 Flare ¿9.5 Flare 7.5 Larger side size Coupler style Smaller side size Coupler style Standard length Maximum actual pipe length (of one way) Maximum height difference If Indoor Unit higher If Outdoor Unit higher Condensate drain pipe diameter INDOOR UNIT Model Appearance colour 7.1 7.9 3 380-415 50 80 43/40/37 53 R407C 1.9 35 Capillary tube & Expansion valve ¿15.9 Flare ¿9.5 Flare 7.5 Refrigerant control Interconnection pipe COOLING 3.1 90 15.0 RAV-264BH-PE mm mm mm kg Specifications are subject to change without notice 4 1. SPECIFICATIONS Item Model Power source Refrigerant Indoor Unit (High, Med, Low) Outdoor Unit Name of Refrigerant Charge Volume Add. Volume (20-50m) kW % A A dB(A) dB(A) Net weight Heat exchanger type Indoor fan type Air volume Fan motor output External static pressure OUTDOOR UNIT Model Appearance colour Dimensions 20 50 ¿32.5 (ID) RAV-364BH-PE Black (zinc galvanized steel & thermal insulator) 345 1,420 875 58 Finned tube Multi-blade fan 1,820 120 4 10 RAV-364AH8-PE Bronze white (Munsell 6Y7.5/1) 1,240 930 385 103 Finned tube Propeller fan 6,000 39 + 63 ZR49KCE-TFD-230 3.0 20 50 ¿32.5 (ID) RAV-464BH-PE Black (zinc galvanized steel & thermal insulator) 345 1,420 875 62 Finned tube Multi-blade fan 2,100 140 4 10 RAV-464AH8-PE Bronze white (Munsell 6Y7.5/1) 1,240 930 385 118 Finned tube Propeller fan 6,000 39 + 63 ZR61KCE-TFD-230 3.75 m m mm m3/h W mmAq mmAq mm mm mm kg kW Protective device High pressure switch, fuse, reverse phase protector, crankcase heater, inner overload relay, delivery temperature sensor Long-life filter kit Dimensions HEATING 5.4 85 9.2 50 mm m3/h W Model Output COOLING 5.15 87 8.5 50 mm mm mm kg Height Width Depth HEATING 3.9 85 6.6 m Height Width Depth Standard Max. motor COOLING 4.2 87 7.0 m kg g/m mm Net weight Heat exchanger type Outdoor fan type Air flow volume Fan motor output Compressor 12.5 13.8 3 380-415 50 50 46/43/40 55 R407C 3.5 50 Capillary tube & Expansion valve ¿19 (¿22) Flare ¿9.5 Flare 7.5 Larger side size* Coupler style Smaller side size Coupler style Standard length Maximum actual pipe length (of one way) Maximum height difference If Indoor Unit higher If Outdoor Unit higher Condensate drain pipe diameter INDOOR UNIT Model Appearance colour Dimensions 10.0 10.8 3 380-415 50 42 45/42/39 55 R407C 2.7 35 Capillary tube & Expansion valve ¿19 (¿22) Flare ¿9.5 Flare 7.5 Refrigerant control Interconnection pipe RAV-464BH-PE kW kW Phase V Hz Cooling capacity Heating capacity Power consumption Power factor Running current Starting current Operating noise (SPL) RAV-364BH-PE Height Width Depth Net weight Air filter mm mm mm kg *(¿22) should be used when length of pipe exceeds 30m Specifications are subject to change without notice 5 RBC-RK462BE-PE RBC-RK462BE-PE 80 1,350 285 12 Washable 80 1,350 285 12 Washable 1. SPECIFICATIONS Item Model RAV-134CH/CHR-PE RAV-164CH/CHR-PE Cooling capacity Heating capacity kW kW Phase V Hz 3.6 4.2 1 220-240 50 4.5 5.0 1 220-240 50 Power source Power consumption Power factor Running current Starting current Operating noise (SPL) Refrigerant Indoor Unit (High, Med, Low) Outdoor Unit Name of Refrigerant Charge Volume Add. Volume (20-30m) COOLING 2.0 88 9.9 kW % A A dB(A) dB(A) Dimensions m m 30 30 15 30 ¿20 (OD) RAV-134CH/CHR-PE Silky Mist 188 1,030 640 24 Finned tube Multi-blade fan 780 34 Washable RAV-134AH-PE Bronze white (Munsell 6Y7.5/1) 740 880 310 61 Finned tube Propeller fan 2,700 39 PG330X3F-4LS 1.5 15 30 ¿20 (OD) RAV-164CH/CHR-PE Silky Mist 188 1,030 640 24 Finned tube Multi-blade fan 850 34 Washable RAV-164AH-PE Bronze white (Munsell 6Y7.5/1) 740 880 310 61 Finned tube Propeller fan 2,700 39 PG350X3F-4LS 1.5 kg g/m mm Height Width Depth mm mm mm kg Net weight Heat exchanger type Indoor fan type Air volume Fan motor output Air filter OUTDOOR UNIT Model Appearance colour Dimensions Net weight Heat exchanger type Outdoor fan type Air flow volume Fan motor output Compressor mm m m mm m3/h W Height Width Depth mm mm mm kg m3/h W Model Output HEATING 2.2 89 10.7 60 43/39/36 50 R407C 1.2 35 Capillary tube & Expansion valve ¿12.7 Flare ¿6.4 Flare 7.5 Larger side size Coupler style Smaller side size Coupler style Standard length Maximum actual pipe length (of one way) Maximum height difference If Indoor Unit higher If Outdoor Unit higher Condensate drain pipe diameter INDOOR UNIT Model Appearance colour COOLING 2.2 90 10.6 60 40/37/33 50 R407C 1.05 35 Capillary tube & Expansion valve ¿12.7 Flare ¿6.4 Flare 7.5 Refrigerant control Interconnection pipe HEATING 2.15 90 10.4 kW High pressure switch, fuse, crankcase heater, inner overload relay, bi-metal thermostat Protective device Specifications are subject to change without notice 6 1. SPECIFICATIONS Item Model RAV-264CH/CHR-PE RAV-264CH/CHR-PE Cooling capacity Heating capacity kW kW Phase V Hz 7.1 7.9 1 220-240 50 7.1 7.9 3 380-415 50 Power source Power consumption Power factor Running current Starting current Operating noise (SPL) Refrigerant Indoor Unit (High, Med, Low) Outdoor Unit Name of Refrigerant Charge Volume Add. Volume (20-30m) COOLING 3.1 90 15.0 kW % A A dB(A) dB(A) Dimensions m m 30 30 15 30 ¿20 (OD) RAV-264CH/CHR-PE Silky Mist 188 1,230 640 28 Finned tube Multi-blade fan 1,200 34 Washable RAV-264AH-PE Bronze white (Munsell 6Y7.5/1) 790 880 310 80 Finned tube Propeller fan 3,000 63 PG460X3F-4MS 2.2 15 30 ¿20 (OD) RAV-264CH/CHR-PE Silky Mist 188 1,230 640 28 Finned tube Multi-blade fan 1,200 34 Washable RAV-264AH8-PE Bronze white (Munsell 6Y7.5/1) 790 880 310 80 Finned tube Propeller fan 3,000 63 YG460X3F-MS 2.2 High pressure switch, fuse, crankcase heater, inner overload relay, bi-metal thermostat High pressure switch, fuse, crankcase heater, overcurrent relay, thermostat, reverse phase protector kg g/m mm Height Width Depth mm mm mm kg Net weight Heat exchanger type Indoor fan type Air volume Fan motor output Air filter OUTDOOR UNIT Model Appearance colour Dimensions Net weight Heat exchanger type Outdoor fan type Air flow volume Fan motor output Compressor mm m m mm m3/h W Height Width Depth mm mm mm kg m3/h W Model Output HEATING 2.95 85 5.0 25 45/41/37 53 R407C 1.9 35 Capillary tube & Expansion valve ¿15.9 Flare ¿9.5 Flare 7.5 Larger side size Coupler style Smaller side size Coupler style Standard length Maximum actual pipe length (of one way) Maximum height difference If Indoor Unit higher If Outdoor Unit higher Condensate drain pipe diameter INDOOR UNIT Model Appearance colour COOLING 2.9 85 4.9 80 45/41/37 53 R407C 1.9 35 Capillary tube & Expansion valve ¿15.9 Flare ¿9.5 Flare 7.5 Refrigerant control Interconnection pipe HEATING 2.95 90 14.2 kW Protective device Specifications are subject to change without notice 7 1. SPECIFICATIONS Item Model RAV-364CH/CHR-PE RAV-464CH/CHR-PE Cooling capacity Heating capacity kW kW Phase V Hz 10.0 10.8 3 380-415 50 12.5 13.8 3 380-415 50 Power source Power consumption Power factor Running current Starting current Operating noise (SPL) Refrigerant Indoor Unit (High, Med, Low) Outdoor Unit Name of Refrigerant Charge Volume Add. Volume (20-50m) COOLING 4.2 87 7.0 kW % A A dB(A) dB(A) Dimensions m m 50 50 20 50 ¿20 (OD) RAV-364CH/CHR-PE Silky Mist 240 1,430 640 39 Finned tube Multi-blade fan 1,680 75 Washable RAV-364AH8-PE Bronze white (Munsell 6Y7.5/1) 1,240 930 385 103 Finned tube Propeller fan 6,000 39 + 63 ZR49KCE-TFD-230 3.0 20 50 ¿20 (OD) RAV-464CH/CHR-PE Silky Mist 240 1,630 640 44 Finned tube Multi-blade fan 2,100 75 Washable RAV-464AH8-PE Bronze white (Munsell 6Y7.5/1) 1,240 930 385 118 Finned tube Propeller fan 6,000 39 + 63 ZR61KCE-TFD-230 3.75 kg g/m mm Height Width Depth mm mm mm kg Net weight Heat exchanger type Indoor fan type Air volume Fan motor output Air filter OUTDOOR UNIT Model Appearance colour Dimensions Net weight Heat exchanger type Outdoor fan type Air flow volume Fan motor output Compressor mm m m mm m3/h W Height Width Depth mm mm mm kg m3/h W Model Output HEATING 5.4 85 9.2 50 49/45/41 55 R407C 3.5 50 Capillary tube & Expansion valve ¿19 (¿22) Flare ¿9.5 Flare 7.5 Larger side size* Coupler style Smaller side size Coupler style Standard length Maximum actual pipe length (of one way) Maximum height difference If Indoor Unit higher If Outdoor Unit higher Condensate drain pipe diameter INDOOR UNIT Model Appearance colour COOLING 5.15 87 8.5 42 47/43/40 55 R407C 2.7 35 Capillary tube & Expansion valve ¿19 (¿22) Flare ¿9.5 Flare 7.5 Refrigerant control Interconnection pipe HEATING 3.9 85 6.6 kW High pressure switch, fuse, reverse phase protector, crankcase heater, inner overload relay, delivery temperature sensor Protective device *(¿22) should be used when length of pipe exceeds 30m Specifications are subject to change without notice 8 1. SPECIFICATIONS Item Model RAV-134KH/KHR-PE RAV-164KH/KHR-PE Cooling capacity Heating capacity kW kW Phase V Hz 3.6 4.2 1 220-240 50 4.5 5.0 1 220-240 50 Power source Power consumption Power factor Running current Starting current Operating noise (SPL) Refrigerant Indoor Unit (High, Med, Low) Outdoor Unit Name of Refrigerant Charge Volume Add. Volume (20-30m) COOLING 2.0 88 9.9 kW % A A dB(A) dB(A) Dimensions m m 30 30 15 30 ¿20 (OD) RAV-134KH/KHR-PE Silky Mist 372 1,150 226 20 Finned tube Transverse flow fan 700 27 Washable RAV-134AH-PE Bronze white (Munsell 6Y7.5/1) 740 880 310 61 Finned tube Propeller fan 2,700 39 PG330X3F-4LS 1.5 15 30 ¿20 (OD) RAV-164KH/KHR-PE Silky Mist 372 1,150 226 20 Finned tube Transverse flow fan 770 27 Washable RAV-164AH-PE Bronze white (Munsell 6Y7.5/1) 740 880 310 61 Finned tube Propeller fan 2,700 39 PG350X3F-4LS 1.5 kg g/m mm Height Width Depth mm mm mm kg Net weight Heat exchanger type Indoor fan type Air volume Fan motor output Air filter OUTDOOR UNIT Model Appearance colour Dimensions Net weight Heat exchanger type Outdoor fan type Air flow volume Fan motor output Compressor mm m m mm m3/h W Height Width Depth mm mm mm kg m3/h W Model Output HEATING 2.2 89 10.7 60 43/39/36 50 R407C 1.2 35 Capillary tube & Expansion valve ¿12.7 Flare ¿6.4 Flare 7.5 Larger side size Coupler style Smaller side size Coupler style Standard length Maximum actual pipe length (of one way) Maximum height difference If Indoor Unit higher If Outdoor Unit higher Condensate drain pipe diameter INDOOR UNIT Model Appearance colour COOLING 2.2 90 10.6 60 42/38/35 50 R407C 1.05 35 Capillary tube & Expansion valve ¿12.7 Flare ¿6.4 Flare 7.5 Refrigerant control Interconnection pipe HEATING 2.15 90 10.4 kW High pressure switch, fuse, crankcase heater, inner overload relay, bi-metal thermostat Protective device Specifications are subject to change without notice 9 1. SPECIFICATIONS Item Model Power source Refrigerant Indoor Unit (High, Med, Low) Outdoor Unit Name of Refrigerant Charge Volume Add. Volume (20-30m) kW % A A dB(A) dB(A) Compressor HEATING 2.95 85 5.0 30 15 30 ¿20 (OD) RAV-264KH/KHR-PE Silky Mist 372 1,478 226 26 Finned tube Transverse flow fan 1,200 27 Washable RAV-264AH-PE Bronze white (Munsell 6Y7.5/1) 790 880 310 80 Finned tube Propeller fan 3,000 63 PG460X3F-4MS 2.2 15 30 ¿20 (OD) RAV-264KH/KHR-PE Silky Mist 372 1,478 226 26 Finned tube Transverse flow fan 1,200 27 Washable RAV-264AH8-PE Bronze white (Munsell 6Y7.5/1) 790 880 310 80 Finned tube Propeller fan 3,000 63 YG460X3F-MS 2.2 mm m m mm m3/h W mm mm mm kg m3/h W Model Output COOLING 2.9 85 4.9 30 mm mm mm kg Net weight Heat exchanger type Outdoor fan type Air flow volume Fan motor output HEATING 2.95 90 14.2 m Height Width Depth Height Width Depth COOLING 3.1 90 15.0 m kg g/m mm Net weight Heat exchanger type Indoor fan type Air volume Fan motor output Air filter OUTDOOR UNIT Model Appearance colour Dimensions 7.1 7.9 3 380-415 50 25 44/40/37 53 R407C 1.9 35 Capillary tube & Expansion valve ¿15.9 Flare ¿9.5 Flare 7.5 Larger side size Coupler style Smaller side size Coupler style Standard length Maximum actual pipe length (of one way) Maximum height difference If Indoor Unit higher If Outdoor Unit higher Condensate drain pipe diameter INDOOR UNIT Model Appearance colour Dimensions 7.1 7.9 1 220-240 50 80 44/40/37 53 R407C 1.9 35 Capillary tube & Expansion valve ¿15.9 Flare ¿9.5 Flare 7.5 Refrigerant control Interconnection pipe RAV-264KH/KHR-PE kW kW Phase V Hz Cooling capacity Heating capacity Power consumption Power factor Running current Starting current Operating noise (SPL) RAV-264KH/KHR-PE kW High pressure switch, fuse, High pressure switch, fuse, bi-metal overcurrent relay, crankcase heater, thermostat, crankcase heater, thermostat, reverse phase protector inner overload relay Protective device Specifications are subject to change without notice 10 1. SPECIFICATIONS Item Model Power source Power consumption Power factor Running current Starting current Operating noise (SPL) Refrigerant Interconnection pipe Indoor Unit (High, Med, Low) Name of Refrigerant Larger side size Coupler style Smaller side size Coupler style Condensate drain pipe diameter Appearance colour Dimensions Net weight Heat exchanger type Indoor fan type Air volume Fan motor output Air filter Phase V Hz kW % A A dB(A) mm mm mm Height Width Depth mm mm mm kg m3/h W Specifications are subject to change without notice 11 RAV-104NH-PE 1 220-240 50 0.07 93 0.33 0.6 40/37/34 R407C ¿12.7 Flare ¿6.4 Flare ¿20 (OD) Zinc, galvanized steel 600 (if top air outlet) 580 (if front outlet) 745 (including drain catch) 230 (if top air outlet) 250 (if front air outlet) 21 Finned tube Multi-blade fan 550 34 Washable 1. SPECIFICATIONS Item Model RAV-134NH-PE RAV-164NH-PE Cooling capacity Heating capacity kW kW Phase V Hz 3.6 4.2 1 220-240 50 4.5 5.0 1 220-240 50 Power source Power consumption Power factor Running current Starting current Operating noise (SPL) Refrigerant Indoor Unit (High, Med, Low) Outdoor Unit Name of Refrigerant Charge Volume Add. Volume (20-30m) kW % A A dB(A) dB(A) Dimensions Dimensions m 30 30 Height Width Depth mm mm mm kg Net weight Heat exchanger type Outdoor fan type Air flow volume Fan motor output Compressor mm m m mm m3/h W Height Width Depth mm mm mm kg m3/h W Model Output HEATING 2.2 89 10.7 m kg g/m mm Net weight Heat exchanger type Indoor fan type Air volume Fan motor output Air filter OUTDOOR UNIT Model Appearance colour COOLING 2.2 90 10.6 60 42/39/36 50 R407C 1.2 35 Capillary tube & Expansion valve ¿12.7 Flare ¿6.4 Flare 7.5 Larger side size Coupler style Smaller side size Coupler style Standard length Maximum actual pipe length (of one way) Maximum height difference If Indoor Unit higher If Outdoor Unit higher Condensate drain pipe diameter INDOOR UNIT Model Appearance colour HEATING 2.15 90 10.4 60 41/38/35 50 R407C 1.05 35 Capillary tube & Expansion valve ¿12.7 Flare ¿6.4 Flare 7.5 Refrigerant control Interconnection pipe COOLING 2.0 88 9.9 kW 15 15 30 30 ¿20 (OD) ¿20 (OD) RAV-164NH-PE RAV-134NH-PE Zinc Zinc (galvanized steel) (galvanized steel) 600 (if top air outlet) 580 (if front air outlet) 600 (if top air outlet) 580 (if front air outlet) 1,045 (including drain catch) 1,045 (including drain catch) 230 (if top air outlet) 250 (if front air outlet) 230 (if top air outlet) 250 (if front air outlet) 25 29 Finned tube Finned tube Multi-blade fan Multi-blade fan 625 740 34 34 Washable Washable RAV-134AH-PE RAV-164AH-PE Bronze white (Munsell 6Y7.5/1) Bronze white (Munsell 6Y7.5/1) 740 740 880 880 310 310 61 61 Finned tube Finned tube Propeller fan Propeller fan 2,700 2,700 39 39 PG330X3F-4LS PG350X3F-4LS 1.5 1.5 High pressure switch, fuse, crankcase heater, inner overload relay, bi-metal thermostat Protective device Specifications are subject to change without notice 12 1. SPECIFICATIONS Item Model RAV-264NH-PE RAV-264NH-PE Cooling capacity Heating capacity kW kW Phase V Hz 5.7 6.7 1 220-240 50 5.7 6.7 3 380-415 50 Power source Power consumption Power factor Running current Starting current Operating noise (SPL) Refrigerant Indoor Unit (High, Med, Low) Outdoor Unit Name of Refrigerant Charge Volume Add. Volume (20-30m) kW % A A dB(A) dB(A) Dimensions Dimensions m 30 30 Height Width Depth mm mm mm kg Net weight Heat exchanger type Outdoor fan type Air flow volume Fan motor output Compressor mm 15 15 30 30 ¿20 (OD) ¿20 (OD) RAV-264NH-PE RAV-264NH-PE Zinc Zinc (galvanized steel) (galvanized steel) 600 (if top air outlet) 580 (if front air outlet) 600 (if top air outlet) 580 (if front air outlet) 1,045 (including drain catch) 1,045 (including drain catch) 230 (if top air outlet) 250 (if front air outlet) 230 (if top air outlet) 250 (if front air outlet) 29 29 Finned tube Finned tube Multi-blade fan Multi-blade fan 900 900 34 34 Washable Washable RAV-264AH-PE RAV-264AH8-PE Bronze white (Munsell 6Y7.5/1) Bronze white (Munsell 6Y7.5/1) 790 790 880 880 310 310 80 80 Finned tube Finned tube Propeller fan Propeller fan 3,000 3,000 63 63 PG460X3F-4MS YG460X3F-MS 2.2 2.2 m m mm m3/h W Height Width Depth mm mm mm kg m3/h W Model Output HEATING 2.8 82 4.9 m kg g/m mm Net weight Heat exchanger type Indoor fan type Air volume Fan motor output Air filter OUTDOOR UNIT Model Appearance colour COOLING 2.8 80 5.1 25 42/39/36 53 R407C 1.9 35 Capillary tube & Expansion valve ¿15.9 Flare ¿9.5 Flare 7.5 Larger side size Coupler style Smaller side size Coupler style Standard length Maximum actual pipe length (of one way) Maximum height difference If Indoor Unit higher If Outdoor Unit higher Condensate drain pipe diameter INDOOR UNIT Model Appearance colour HEATING 2.8 90 13.5 80 42/39/36 53 R407C 1.9 35 Capillary tube & Expansion valve ¿15.9 Flare ¿9.5 Flare 7.5 Refrigerant control Interconnection pipe COOLING 2.8 90 13.7 kW High pressure swich, fuse, crankcase heater, inner overload relay, bi-metal thermostat Protective device Specifications are subject to change without notice 13 High pressure switch, fuse, crankcase heater, overcurrent relay, thermostat, reverse phase protector 1. SPECIFICATIONS Item Model RAV-164SH/SHR-PE Cooling capacity Heating capacity kW kW Phase V Hz 4.5 5.0 1 220-240 50 Power source Power consumption Power factor Running current Starting current Operating noise (SPL) Refrigerant Indoor Unit (High, Med, Low) Outdoor Unit Name of Refrigerant Charge Volume Add. Volume (20-30m) kW % A A dB(A) dB(A) m m 30 kg g/m Larger side size Coupler style Smaller side size Coupler style Standard length Maximum actual pipe length (of one way) Maximum height difference If Indoor Unit higher If Outdoor Unit higher mm Height Width Depth mm mm mm kg Condensate drain pipe diameter INDOOR UNIT Model Appearance colour Dimensions Net weight Heat exchanger type Indoor fan type Air volume Fan motor output Air filter OUTDOOR UNIT Model Appearance colour Dimensions Net weight Heat exchanger type Outdoor fan type Air flow volume Fan motor output Compressor mm 15 30 ¿20 (OD) RAV-164SH/SHR-PE Silky Mist 640 1,030 188 24 Finned tube Multi-blade fan 850 34 Washable RAV-164AH-PE Bronze white (Munsell 6Y7.5/1) 740 880 310 61 Finned tube Propeller fan 2,700 39 PG350X3F-4LS 1.5 m m mm m3/h W Height Width Depth mm mm mm kg m3/h W Model Output HEATING 2.2 89 10.7 60 42/39/36 50 R407C 1.2 35 Capillary tube & Expansion valve ¿12.7 Flare ¿6.4 Flare 7.5 Refrigerant control Interconnection pipe COOLING 2.2 90 10.6 kW High pressure switch, fuse, bi-metal thermostat, crankcase heater, inner overload relay Protective device Specifications are subject to change without notice 14 1. SPECIFICATIONS Item Cooling capacity Heating capacity Power source Power consumption Power factor Running current Starting current Operating noise (SPL) Refrigerant Indoor Unit (High, Med, Low) Outdoor Unit Name of Refrigerant Charge Volume Add. Volume (20-30m) Model RAV-264SH/SHR-PE RAV-264SH/SHR-PE kW kW Phase V Hz 7.1 7.9 1 220-240 50 7.1 7.9 3 380-415 50 kW % A A dB(A) dB(A) Dimensions Dimensions m 30 30 15 30 ¿20 (OD) RAV-264SH/SHR-PE Silky Mist 640 1,230 188 28 Finned tube Multi-blade fan 1,200 34 Washable RAV-264AH-PE Bronze white (Munsell 6Y7.5/1) 790 880 310 80 Finned tube Propeller fan 3,000 63 PG460X3F-4MS 2.2 15 30 ¿20 (OD) RAV-264SH/SHR-PE Silky Mist 640 1,230 188 28 Finned tube Multi-blade fan 1,200 34 Washable RAV-264AH8-PE Bronze white (Munsell 6Y7.5/1) 790 880 310 80 Finned tube Propeller fan 3,000 63 YG460X3F-MS 2.2 High pressure switch, fuse, crankcase heater, inner overload relay, bi-metal thermostat High pressure switch, fuse, crankcase heater, overcurrent relay, thermostat, reverse phase protector Height Width Depth mm mm mm kg Net weight Heat exchanger type Outdoor fan type Air flow volume Fan motor output Compressor mm m m mm m3/h W Height Width Depth mm mm mm kg m3/h W Model Output HEATING 2.95 85 5.0 m kg g/m mm Net weight Heat exchanger type Indoor fan type Air volume Fan motor output Air filter OUTDOOR UNIT Model Appearance colour COOLING 2.9 85 4.9 25 44/39/36 53 R407C 1.9 35 Capillary tube & Expansion valve ¿15.9 Flare ¿9.5 Flare 7.5 Larger side size Coupler style Smaller side size Coupler style Standard length Maximum actual pipe length (of one way) Maximum height difference If Indoor Unit higher If Outdoor Unit higher Condensate drain pipe diameter INDOOR UNIT Model Appearance colour HEATING 2.95 90 14.2 80 44/39/36 53 R407C 1.9 35 Capillary tube & Expansion valve ¿15.9 Flare ¿9.5 Flare 7.5 Refrigerant control Interconnection pipe COOLING 3.1 90 15.0 kW Protective device Specifications are subject to change without notice 15 1. SPECIFICATIONS Item Model Power source Power consumption Power factor Running current Starting current Operating noise (SPL) Refrigerant Interconnection pipe Indoor Unit (High, Med, Low) Name of Refrigerant Larger side size Coupler style Smaller side size Coupler style Condensate drain pipe diameter Appearance colour Dimensions Net weight Heat exchanger type Indoor fan type Air volume Fan motor output CEILING PANEL model Appearance colour Dimensions Phase V Hz kW % A A dB(A) mm mm mm Height Width Depth mm mm mm kg m3/h W Height Width Depth Net weight Air filter mm mm mm kg Specifications are subject to change without notice 16 RAV-104TUH-PE 1 220-240 50 0.07 93 0.33 0.6 40/36/34 R407C ¿12.7 Flare ¿6.4 Flare ¿25.5 (OD) Grey (galvanized steel& thermal insulation) 190 910 480 23 Finned tube Transverse flow fan 550 7x2 RBC-U133PG(W)-PE Silky white (Munsell 2.9Y8.9/0.8) 25 1,050 550 4.5 Washable 1. SPECIFICATIONS Item Cooling capacity Heating capacity Power source Power consumption Power factor Running current Starting current Operating noise (SPL) Refrigerant Indoor Unit (High, Med, Low) Outdoor Unit Name of Refrigerant Charge Volume Add. Volume (20-30m) Model RAV-134TUH-PE RAV-164TUH-PE kW kW Phase V Hz 3.6 4.2 1 220-240 50 4.5 5.0 1 220-240 50 kW % A A dB(A) dB(A) Dimensions Dimensions m 30 30 15 30 ¿25.5 (OD) RAV-134TUH-PE Grey (galvanized steel & thermal insulator) 190 910 480 23 Finned tube Transverse flow fan 700 7x2 RAV-134AH-PE Bronze white (Munsell 6Y7.5/1) 740 880 310 61 Finned tube Propeller fan 2,700 39 PG330X3F-4LS 1.5 15 30 ¿25.5 (OD) RAV-164TUH-PE Grey (galvanized steel & thermal insulator) 190 910 480 23 Finned tube Transverse flow fan 750 7x2 RAV-164AH-PE Bronze white (Munsell 6Y7.5/1) 740 880 310 61 Finned tube Propeller fan 2,700 39 PG350X3F-4LS 1.5 Height Width Depth mm mm mm kg Net weight Heat exchanger type Outdoor fan type Air flow volume Fan motor output Compressor mm m m mm m3/h W Height Width Depth mm mm mm kg m3/h W Model Output kW High pressure switch, fuse, crankcase heater, inner overload relay, bi-metal thermostat Protective device CEILING PANEL model Appearance colour Dimensions HEATING 2.2 89 10.7 m kg g/m mm Net weight Heat exchanger type Indoor fan type Air volume Fan motor output OUTDOOR UNIT Model Appearance colour COOLING 2.2 90 10.6 60 41/37/35 50 R407C 1.2 35 Capillary tube & Expansion valve ¿12.7 Flare ¿6.4 Flare 7.5 Larger side size Coupler style Smaller side size Coupler style Standard length Maximum actual pipe length (of one way) Maximum height difference If Indoor Unit higher If Outdoor Unit higher Condensate drain pipe diameter INDOOR UNIT Model Appearance colour HEATING 2.15 90 10.4 60 40/36/34 50 R407C 1.05 35 Capillary tube & Expansion valve ¿12.7 Flare ¿6.4 Flare 7.5 Refrigerant control Interconnection pipe COOLING 2.0 88 9.9 Height Width Depth Net weight RBC-U133PG(W)-PE Silky white (Munsell 2.9Y8.9/0.8) 25 1,050 550 4.5 Washable mm mm mm kg Air filter Specifications are subject to change without notice 17 RBC-U133PG(W)-PE Silky white (Munsell 2.9Y8.9/0.8) 25 1,050 550 4.5 Washable 1. SPECIFICATIONS Item Model RAV-164UH-PE Cooling capacity Heating capacity kW kW Phase V Hz 4.5 5.0 1 220-240 50 Power source Power consumption Power factor Running current Starting current Operating noise (SPL) Refrigerant Indoor Unit (High, Med, Low) Outdoor Unit Name of Refrigerant Charge Volume Add. Volume (20-30m) kW % A A dB(A) dB(A) m m 30 kg g/m Larger side size Coupler style Smaller side size Coupler style Standard length Maximum actual pipe length (of one way) Maximum height difference If Indoor Unit higher If Outdoor Unit higher mm Height Width Depth mm mm mm kg Condensate drain pipe diameter INDOOR UNIT Model Appearance colour Dimensions Net weight Heat exchanger type Indoor fan type Air volume Fan motor output OUTDOOR UNIT Model Appearance colour Dimensions Net weight Heat exchanger type Outdoor fan type Air flow volume Fan motor output Compressor mm m m mm 15 30 1" BSP (male threaded connection) RAV-164UH-PE Black (zinc galvanized steel & thermal insulator) 259 820 820 25 Finned tube Centrifugal fan 1,020 28 RAV-164AH-PE Bronze white (Munsell 6Y7.5/1) 740 880 310 61 Finned tube Propeller fan 2,700 39 PG350X3F-4LS 1.5 m3/h W Height Width Depth mm mm mm kg m3/h W Model Output kW High pressure switch, fuse, bi-metal thermostat, crankcase heater, inner overload relay Protective device RBC-U264PG(W)-E RBC-U264PGR(W)-E White 20 940 940 6 Washable CEILING PANEL model Appearance colour Dimensions HEATING 2.2 89 10.7 60 38/35/32 50 R407C 1.2 35 Capillary tube & Expansion valve ¿12.7 Flare ¿6.4 Flare 7.5 Refrigerant control Interconnection pipe COOLING 2.2 90 10.6 Height Width Depth Net weight Air filter mm mm mm kg Specifications are subject to change without notice 18 1. SPECIFICATIONS Item Model RAV-264UH-PE RAV-264UH-PE Cooling capacity Heating capacity kW kW Phase V Hz 7.1 7.9 1 220-240 50 7.1 7.9 3 380-415 50 Power source Power consumption Power factor Running current Starting current Operating noise (SPL) Refrigerant Indoor Unit (High, Med, Low) Outdoor Unit Name of Refrigerant Charge Volume Add. Volume (20-30m) kW % A A dB(A) dB(A) Dimensions Dimensions m 30 30 15 30 1" BSP (male threaded connection) RAV-264UH-PE Black (zinc galvanized steel & thermal insulator) 259 820 820 25 Finned tube Centrifugal fan 1,260 28 RAV-264AH-PE Bronze white (Munsell 6Y7.5/1) 790 880 310 80 Finned tube Propeller fan 3,000 63 PG460X3F-4MS 2.2 15 30 1" BSP (male threaded connection) RAV-264UH-PE Black (zinc galvanized steel & thermal insulator) 259 820 820 25 Finned tube Centrifugal fan 1,260 28 RAV-264AH8-PE Bronze white (Munsell 6Y7.5/1) 790 880 310 80 Finned tube Propeller fan 3,000 63 YG460X3F-MS 2.2 High pressure switch, fuse, crankcase heater, inner overload relay, bi-metal thermostat High pressure switch, fuse, crankcase heater, overcurrent relay, thermostat, reverse phase protector RBC-U264PG(W)-E RBC-U264PGR(W)-E White 20 940 940 6 Washable RBC-U264PG(W)-E RBC-U264PGR(W)-E White 20 940 940 6 Washable Height Width Depth mm mm mm kg Net weight Heat exchanger type Outdoor fan type Air flow volume Fan motor output Compressor mm m m mm m3/h W Height Width Depth mm mm mm kg m3/h W Model Output kW Protective device CEILING PANEL model Appearance colour Dimensions Height Width Depth Net weight Air filter HEATING 2.95 85 5.0 m kg g/m mm Net weight Heat exchanger type Indoor fan type Air volume Fan motor output OUTDOOR UNIT Model Appearance colour COOLING 2.9 85 4.9 25 43/39/35 50 R407C 1.9 35 Capillary tube & Expansion valve ¿15.9 Flare ¿9.5 Flare 7.5 Larger side size Coupler style Smaller side size Coupler style Standard length Maximum actual pipe length (of one way) Maximum height difference If Indoor Unit higher If Outdoor Unit higher Condensate drain pipe diameter INDOOR UNIT Model Appearance colour HEATING 2.95 90 14.2 80 43/39/35 50 R407C 1.9 35 Capillary tube & Expansion valve ¿15.9 Flare ¿9.5 Flare 7.5 Refrigerant control Interconnection pipe COOLING 3.1 90 15.0 mm mm mm kg Specifications are subject to change without notice 19 1. SPECIFICATIONS Item Cooling capacity Heating capacity Power source Power consumption Power factor Running current Starting current Operating noise (SPL) Refrigerant Indoor Unit (High, Med, Low) Outdoor Unit Name of Refrigerant Charge Volume Add. Volume (20-50m) Model RAV-364UH-PE RAV-464UH-PE kW kW Phase V Hz 10.0 10.8 3 380-415 50 12.5 13.8 3 380-415 50 kW % A A dB(A) dB(A) Dimensions Dimensions m 50 50 Height Width Depth mm mm mm kg Net weight Heat exchanger type Outdoor fan type Air flow volume Fan motor output Compressor mm m m mm m3/h W Height Width Depth mm mm mm kg m3/h W Model Output kW 20 20 50 50 1" BSP (male threaded connection) 1" BSP (male threaded connection) RAV-464UH-PE RAV-364UH-PE Black (zinc galvanized steel & Black (zinc galvanized steel & thermal insulator) thermal insulator) 309 309 1,230 1,230 820 820 43 43 Finned tube Finned tube Centrifugal fan Centrifugal fan 1,750 1,820 36 36 RAV-364AH8-PE RAV-464AH8-PE Bronze white (Munsell 6Y7.5/1) Bronze white (Munsell 6Y7.5/1) 1,240 1,240 930 930 385 385 103 118 Finned tube Finned tube Propeller fan Propeller fan 6,000 6,000 39 + 63 39 + 63 ZR49KCE-TFD-230 ZR61KCE-TFD-230 3.0 3.75 High pressure switch, fuse, reverse phase protector, crankcase heater, inner overload relay, delivery temperature sensor Protective device RBC-U464PG(W)-E RBC-U464PGR(W)-E White 20 1,350 940 8 Washable CEILING PANEL model Appearance colour Dimensions HEATING 5.4 85 9.2 m kg g/m mm Net weight Heat exchanger type Indoor fan type Air volume Fan motor output OUTDOOR UNIT Model Appearance colour COOLING 5.15 87 8.5 50 45/43/40 55 R407C 3.5 50 Capillary tube & Expansion valve ¿19 (¿22) Flare ¿9.5 Flare 7.5 Larger side size* Coupler style Smaller side size Coupler style Standard length Maximum actual pipe length (of one way) Maximum height difference If Indoor Unit higher If Outdoor Unit higher Condensate drain pipe diameter INDOOR UNIT Model Appearance colour HEATING 3.9 85 6.6 42 42/40/37 55 R407C 2.7 35 Capillary tube & Expansion valve ¿19 (¿22) Flare ¿9.5 Flare 7.5 Refrigerant control Interconnection pipe COOLING 4.2 87 7.0 Height Width Depth Net weight Air filter mm mm mm kg *(¿22) should be used when length of pipe exceeds 30m Specifications are subject to change without notice 20 RBC-U464PG(W)-E RBC-U464PGR(W)-E White 20 1,350 940 8 Washable 2. CONSTRUCTION VIEWS 2.1 Indoor Unit RAV-164BH-PE RAV-264BH-PE RAV-364BH-PE RAV-464BH-PE Rear return air inlet knockouts 320 Electrical box Thermal insulator Unit dimension: 800 Hanging bolt pitch: B 80 60 305 345 60 80 90 120 Refrigerant piping joint (Gas ¿F) H 150 J=MxK 80 6-¿4 Mounting screw hole ¿160 210 320 320 Hanging bolt pitch: 565 720 630 340 11 70 75 100 Hanging bolt 4-M10 Provided at site 170 Unit dimension: A Air outlet N-¿200 270 Refrigerant piping joint (Liquid ¿G) Drain pipe connection port (Inner diameter: 32.5) ¿125 Knockout hole (rear) (Fresh air inlet) (Port diameter: nominal for PVC pipes) ¿35 Wiring connection port Lower return Air inlet Ensure that there is sufficient space around the indoor unit for installation and servicing 300-400 Inspection hole 450 200 Indoor unit 450 Provide an inspection hole in this position Model A RAV-164BH-PE 700 RAV-264BH-PE 1000 RAV-364BH-PE 1350 RAV-464BH-PE 1350 B 750 1050 1400 1400 F 12.7 15.9 19.0 19.0 G 6.4 9.5 9.5 9.5 H 252 252 252 252 J 280 580 930 930 K 280 290 310 310 M 1 2 3 3 N 2 3 4 4 (Unit : mm) 21 2. CONSTRUCTION VIEWS 2.2 Indoor Unit RAV-134CH/CHR-PE RAV-164CH/CHR-PE RAV-264CH/CHR-PE RAV-364CH/CHR-PE RAV-464CH/CHR-PE Drain piping joint Refrigerant pipe connection (Gas ¿G) 78 12 145 80 80 85 62 34 Hard vinyl chloride pipe outer dia. 20mm Refrigerant pipe connection (Liquid ¿F) Alternative Knock-out hole for drain piping 30 140 50 Right-side panel knock-out for piping and wiring 130 50 150 180 200 170 100 10 Hanging bolt hole 4 - (12x25) Slot Knock-out holes for piping and wiring 85 12 120 30 Air filter C 640 250 Hanging bolt pitch Air inlet B (Hanging bolt pitch) A Hanging bolt Less than 40 E 40 B Inner hanging bolt pitch Outer hanging bolt pitch Greater than 500 Hanging bolt Less than 40 D Hanging plate (Right) 130 Hanging plate (Left) 150 Minimum 150 Minimum Space required for service and installation Greater than 400 Model A B C D E F G RAV-134CH/CHR-PE RAV-164CH/CHR-PE RAV-264CH/CHR-PE RAV-364CH/CHR-PE RAV-464CH/CHR-PE 1,030 1,030 1,230 1,430 1,630 920 920 1,120 540 540 540 550 550 188 188 188 1,020 1,020 1,220 240 240 1,420 1,620 6.4 6.4 9.5 9.5 9.5 12.7 12.7 15.9 19.0 19.0 1,320 1,520 (unit : mm) 22 2. CONSTRUCTION VIEWS 2.3 Indoor Unit RAV-134KH/KHR-PE RAV-164KH/KHR-PE RAV-264KH/KHR-PE 158 143 226 A 216 Refrigerant pipe connection (Gas ¿B) ¿20 (OD.) 372 595 495 (Both sides) Piping hole 40 (Knockout hole) 900 Drain pipe 40 Air outlet 4-way adjustable Refrigerant pipe connection (Liquid ¿C) Piping hole (Knockout hole) MODEL A B C RAV-134KH/KHR-PE 1150 12.7 6.4 RAV-164KH/KHR-PE 1150 12.7 6.4 RAV-264KH/KHR-PE 1478 15.9 9.5 70 118 More than 30 More than 300 RAV-134KH/KHR-PE RAV-164KH/KHR-PE More than 300 Space required for service 20 40 110 150 110 40 20 26 50 40 169 Slots 18-6x30 6-¿6 Holes 50 43 150 (unit : mm) 600 Anchor bolt holes 4 - 10x20 slots RAV-264KH/KHR-PE 150 150 150 150 110 40 20 26 50 Slots 21-6x30 8-¿6 Holes 940 Anchor bolt holes 4 - 10x20 slots Installation board mounting bolt hole location 23 169 110 50 43 20 40 2. CONSTRUCTION VIEWS 2.4 Indoor Unit RAV-104NH-PE RAV-134NH-PE RAV-164NH-PE RAV-264NH-PE Space required for service and installation A 145 160 140 60 20 Upper plate / Duct plate B 95 Fixing location to floor / base Hx¿4.7 hole C D 10 20 100 Air outlet 150 Minimum 10 Flare joint Liquid ¿F 2xø4.7 Hole 133 70 175 Flare joint Gas ¿G 4xø15 hole Fixing location to wall 145 315 345 Drain catch Drain hose connector (OD ø20) 274 224 436 397 Air filter Air intake E 65 95 Electrical box Earth connection inside 110 155 230 Model A B C D E ¿F ¿G H RAV-104NH-PE 580 550 610 4x100 580 6.4 12.7 5 RAV-134NH-PE RAV-164NH-PE RAV-264NH-PE 880 850 910 7x100 880 6.4 12.7 9.5 15.9 8 (Units : mm) 24 Fixing location to floor / base 104 140 70 160 600 10 150 Minimum 25 65 2. CONSTRUCTION VIEWS 2.5 Indoor Unit RAV-164SH/SHR-PE RAV-264SH/SHR-PE Drain piping joint 34 Refrigerant pipe connection (Gas ¿G) 78 12 145 80 80 85 62 Hard vinyl chloride pipe outer dia. 20mm Refrigerant pipe connection (Liquid ¿F) Alternative Knock-out hole for drain piping 30 140 50 Right-side panel knock-out for piping and wiring 130 50 150 180 200 170 100 10 Hanging bolt hole 4 - (12x25) Slot Knock-out holes for piping and wiring 85 Air filter C 640 250 Hanging bolt pitch Air inlet B (Hanging bolt pitch) A Hanging plate (Right) Hanging bolt Less than 40 130 Hanging plate (Left) B Hanging bolt pitch 150 Minimum 150 Minimum PLAN VIEW Greater than 400 D 12 120 30 Greater than 500 Space required for service and installation A B C D F G RAV-164SH-PE RAV-164SHR-PE Model 1,030 920 540 188 6.4 12.7 RAV-264SH-PE RAV-264SHR-PE 1,230 1120 540 188 9.5 15.9 (unit : mm) 25 2. CONSTRUCTION VIEWS 2.6 Indoor Unit RAV-104TUH-PE RAV-134TUH-PE RAV-164TUH-PE 80 480 290 Drain pipe joint (outer ¿25.5) Hanger bolt (4-M10) 70 Refrigerant piping joint (Liquid ¿6.4) Refrigerant piping joint (Gas ¿12.7) 840 110 131 25 96 156 190 190 Wiring connection A Panel outer dimension 1050 Ceiling opening 1010 Hang bolt pitch 930 20 40 70 1050 Ceiling opening 510 480 Hang bolt pitch 410 Panel outer dimension 550 550 TOSHIBA View A 200 (Unit: mm) 600 Minimum 840 40 600 Minimum 600 Minimum Space required for service and installation 26 20 40 110 90 66 73 2. CONSTRUCTION VIEWS 2.7 Indoor Unit RAV-164UH-PE RAV-264UH-PE 185 73 140 240 138 195 39 20 Ceiling Drain pipe connection (1" BSP threaded connection) Knockout for side ducts ¿150 (both sides) 30 40 405 400 Model (RAV-) 164UH 264UH ¿A ¿B 12.7 6.4 15.9 9.5 800 (Hanger bolt pitch) 820 (External cassette dimension) 880 (Ceiling opening) 940 (Panel dimension) 195 536 268 Wiring connection (Gland plate 3x¿20 holes) 940 138 30 200 Refrigerant pipe connection (Liquid ¿B) 106 259 298 160 Refrigerant pipe connection (Gas ¿A) 170 100 80 106 Fresh air inlet Condensate pipe 1" BSP threaded connection Fresh air inlet duct size Side outlet duct size ¿100 4 - ¿6 45° ¿180 0 130 ¿30 ¿144 4 ¿130 ¿97 130 ¿18 ¿14 80 6 - ¿6 10 80 10 45° 45° 30 2 27 45° ¿200 32 940 ¿150 536 620 (Hanger bolt pitch) 820 (External cassette dimension) 880 (Ceiling opening) 940 (Panel dimension) 130 30 30 6 2. CONSTRUCTION VIEWS 2.8 Indoor Unit RAV-364UH-PE RAV-464UH-PE 185 Knockout for side ducts ¿150 (both sides) 941 106 Refrigerant pipe connection (Gas side ¿19.0) 170 100 20 30 Drain pipe connection (1" BSP threaded connection) 610 605 800 (Hanger bolt pitch) 820 (External cassette dimension) 880 (Ceiling opening) 940 (Panel dimension) 40 Wiring connection (Gland plate 3x¿20 holes) Fresh air inlet 940 1030 (Hanger bolt pitch) 1230 (External cassette dimension) 30 130 Condensate pipe 1" BSP threaded connection 1350 1290 (Ceiling opening) 1350 (Panel opening) Fresh air inlet duct size Side outlet duct size 80 10 130 10 45° ¿180 ¿18 45° 30 2 45° 28 45° ¿200 4 ¿130 80 6 - ¿6 0 ¿14 ¿97 130 4 - ¿6 ¿150 ¿100 ¿30 ¿144 32 30 6 200 73 140 Ceiling Ceiling panel 940 39 240 30 30 138 Refrigerant pipe connection (Liquid side ¿9.5) 202 138 348 309 210 106 80 2. CONSTRUCTION VIEWS 2.9 Outdoor Unit RAV-134AH-PE RAV-164AH-PE RAV-264AH-PE RAV-264AH8-PE 360 Refrigerant pipe connection (Gas ¿ D) 12 340 30 70 70 50 280 40 12 Knock-out hole for drain (2-20x60 slots) Hole for drain (2x¿19 hole) 165 117 Refrigerant pipe connection (Liquid ¿ C) 50 45 Electric parts box 310 Air outlet 880 104 Anchor bolt hole (4-12x18slots) Earth screw (M6) 45 790 Terminal cover A 500 Handle (Both sides) 18 B 90 88 320 37 364 Blow out guide mounting hole (4-¿3 embosses) 566 Space required for service Outlet 500 100 500 300 100 100 (Space for wiring and piping) (Space for wiring and piping) When installed with the inlet facing the wall Outlet When installed with the outlet facing the wall Model A B ¿C ¿D RAV-134AH-PE RAV-164AH-PE 740 380 6.4 12.7 RAV-264AH-PE RAV-264AH8-PE 790 430 9.5 15.9 (unit : mm) 29 2. CONSTRUCTION VIEWS 2.10 Outdoor Unit RAV-364AH8-PE RAV-464AH8-PE Knock-out hole for drain (2-30x80 slots) 44 416 80 30 30 12 Refrigerant pipe connection (Gas ¿19) 360 55 Air inlet 125 Air inlet Refrigerant pipe connection (Liquid ¿9.5) 29 12 50 Air outlet 45 Handle (front side only) Earth screw (M6) 45 840 Anchor bolt hole (4-12x18 slots) Terminal cover Handle (Both sides) Air outlet 385 930 500 115 1240 615 500 299 245 50 275 90 37 18 73 150 70 440 566 Blow out guide mounting hole (8-¿3 embosses) Knock-out hole (¿40) 150 Space required for service 150 (Space for wiring and piping) 500 150 300 Outlet (Space for wiring and piping) When installed with the inlet facing the wall 500 Outlet When installed with the outlet facing the wall 30 (unit : mm) 3. WIRING DIAGRAMS 3.1 RAV-164BH-PE RAV-264BH-PE RAV-364BH-PE RAV-464BH-PE Connector assembly (accessory) TC TA CN05 (TC) CN04 (TA) GRY GRY CN15 (LAN) CN12 RY03 L RY02 UL 5 5 7 7 9 9 RED BRW BLK ORG BLU YEL BLU YEL RED GRN/YEL GRY FM WHI RC RY01 (output) CN09 (WHI). (LOUVER) 4 3 2 1 CN21 WHI 4 3 2 1 FM RED CN01 (TRANS) ORG BLU BLK YEL (Fan speed increase option) RED BRW BLK ORG BLU YEL CN07 (FAN) H BLK 1 1 M ORG 3 3 RY04 REMOCON ORG 1 1 YEL 2 2 BLU 3 3 CN02 RED BLK ORG BLU YEL 3 3 1 1 RY06 RY07 RED RY01 1 1 (L1) (N) 1 3 1 3 CN03 (SERIAL) 5 5 BLK 3 3 GRY F 5 5 RED GRY CN10 (PUMP) 7 7 RED TR GRN/YEL 1 2 3 1 2 3 L N Indoor unit (1 Phase model) Y X B A C F2 Earth Screw Power Supply 220/240V ~50Hz X Y Central Remote Controller (Optional) A B C Remote Controller (Optional) 1 (3 Phase model) 2 3 L2 L3 F2 Earth Screw L1 N Power Supply 380/415V 3N~50Hz Outdoor unit Symbol FM RC TR F shows terminal block and figures show terminal numbers. Broken lines show wiring at site. Do not operate the units with the magnetic contactor pushed in. 31 Name Symbol Name TA Sensor Fan Motor TC Sensor Running Capacitor RY01~RY07 Relay Transformer Fuse (PCB) 3. WIRING DIAGRAMS 3.2 RAV-134CH/CHR-PE RAV-164CH/CHR-PE RAV-264CH/CHR-PE RAV-364CH/CHR-PE RAV-464CH/CHR-PE TC TA GRY GRY CN04 CN15 (TA) (LAN) ORG YEL BLU CN02 1 1 2 2 3 3 CN12 L RY02 GRY FM BLU 5 5 WHI UL 7 7 YEL RC RED 9 9 RY01 (output) CN09 (WHI). (LOUVER) CN21 BLK GM 4 3 2 1 BLK CN01 (TRANS) 4 3 2 1 RY03 GRN/YEL WHI ORG BLU BLK YEL RED CN07 (FAN) BLK H 1 1 M ORG 3 3 RY04 REMOCON CN02 CN05 (TC) 3 3 RY01 RY07 RY06 RED 1 1 1 1 RED (L1) (N) 1 3 1 3 CN03 (SERIAL) 5 5 BLK 3 3 GRY F 5 5 7 7 GRY CN10 (PUMP) RED TR Infra-Red Receiver (CHR models) GRN/YEL A B C 1 2 3 1 2 3 L N Indoor unit (1 Phase model) Y X A B C F2 Earth Screw Power Supply 220/240V ~50Hz X Y Central Remote Controller (Optional) A B C Remote Controller (Not CHR models) (Optional) 1 (3 Phase model) 2 3 L2 L3 F2 Earth Screw L1 N Power Supply 380/415V 3N~50Hz Outdoor unit Symbol FM RC TR F shows terminal block and figures show terminal numbers. Broken lines show wiring at site. Do not operate the units with the magnetic contactor pushed in. 32 Name Symbol TA Fan Motor TC Running Capacitor GM Transformer Fuse (PCB) RY01~RY07 Name Sensor Sensor Geared Motor Relay 3. WIRING DIAGRAMS 3.3 RAV-134KH/KHR-PE RAV-164KH/KHR-PE RAV-264KH/KHR-PE TC TA CN05 (TC) 9 9 5 5 BLU 3 3 UL 7 7 YEL 1 1 L RY03 RY02 9 9 7 7 5 5 BLK ORG BLU FM YEL RED WHI RED RED RY01 (output) 4 3 2 1 RC WHI GRY GM CN09 (WHI). (LOUVER) CN21 WHI CN01 (TRANS) ORG 4 BLU 3 BLK 2 YEL 1 CN07 (FAN) H BLK 1 1 ORG M 3 3 BLK CN12 RY04 REMOCON ORG 1 1 YEL 2 2 BLU 3 3 CN02 BLK CN04 CN15 (TA) (LAN) GRY GRY 3 3 RY06 RY01 RY07 RED 1 1 1 1 1 1 (N) 3 3 CN03 (SERIAL) 5 5 BLK 3 3 GRY F (L1) 5 5 RED GRY CN10 (PUMP) 7 7 RED TR Infra-Red Receiver (KHR models) GRN/YEL A C B 1 2 3 1 2 3 L N Indoor unit (1 Phase model) Y X A B C F2 Earth Screw Power Supply 220/240V ~50Hz X Y Central Remote Controller (Optional) A B C Remote Controller (Not KHR models) (Optional) 1 (3 Phase model) 2 3 L2 L3 F2 Earth Screw L1 Outdoor unit Symbol FM RC TR F shows terminal block and figures show terminal numbers. Broken lines show wiring at site. Do not operate the units with the magnetic contactor pushed in. 33 N Power Supply 380/415V 3N~50Hz Name Symbol TA Fan Motor TC Running Capacitor Transformer GM Fuse (PCB) RY01~RY07 Name Sensor Sensor Geared Motor Relay 3. WIRING DIAGRAMS 3.4 RAV-104NH-PE RAV-134NH-PE RAV-164NH-PE RAV-264NH-PE TA CN05 (TC) CN04 CN15 (TA) (LAN) 1 1 2 2 3 3 CN02 CN12 WHI CN01 (TRANS) ORG 4 BLU 3 BLK 2 YEL 1 CN07 (FAN) BLK H 1 1 ORG M 3 3 RY04 REMOCON GRY GRY ORG YEL BLU TC L RY03 5 5 BLU UL 7 7 YEL RY02 9 9 GRN/YEL 6 5 4 3 2 1 6 5 4 3 2 1 BLK ORG BLU GRY FM WHI YEL RED RC RED RY01 (output) 4 3 2 1 CN09 (WHI). (LOUVER) CN21 CN16 3 3 1 1 RY07 RY06 F (L1) 1 1 5 5 BLK 3 3 GRY 5 5 CN03 (SERIAL) (N) 1 3 1 3 RED GRY CN10 (PUMP) 7 7 RED TR RED RY01 GRN/YEL 1 2 3 1 2 3 Indoor unit (1 Phase model) Y X B A C F2 Earth Screw N L Power Supply 220/240V ~50Hz X Y Central Remote Controller (Optional) A B C Remote Controller (3 Phase model) 1 2 3 L1 L2 L3 F2 Earth Screw (Optional) Outdoor unit shows terminal block and figures show terminal numbers. Broken lines show wiring at site. Do not operate the units with the magnetic contactor pushed in. 34 N Power Supply 380/415V 3N~50Hz Symbol FM RC TR F Name Symbol Name Fan Motor TA Sensor Running Capacitor TC Sensor Transformer RY01~RY07 Relay Fuse (PCB) 3. WIRING DIAGRAMS 3.5 RAV-164SH/SHR-PE RAV-264SH/SHR-PE TA TC RED CN05 (TC) CN04 CN15 (TA) (LAN) GRY GRY ORG YEL BLU 1 1 2 2 3 3 RY04 REMOCON CN02 CN12 RY03 L RY02 UL 5 5 7 7 9 9 GRN/YEL GRY FM BLU WHI YEL RED RC RY01 (output) 4 3 2 1 CN09 (WHI). (LOUVER) CN21 WHI CN01 (TRANS) ORG 4 BLU 3 BLK 2 YEL 1 CN07 (FAN) H BLK 1 1 M ORG 3 3 CN16 3 3 RY07 RY06 RY01 RED 1 1 (L1) 1 1 1 1 (N) 3 3 CN03 (SERIAL) 5 5 BLK 3 3 RED GRY 5 5 GRY F CN10 (PUMP) 7 7 RED TR Infra-Red Receiver (SHR models) GRN/YEL A B C 1 2 3 1 2 3 Indoor unit (1 Phase model) Y X B A C F2 Earth Screw N L Power Supply 220/240V ~50Hz X Y Central Remote Controller (Optional) A B 1 C Remote Controller (Not SHR models) (Optional) (3 Phase model) 2 3 L2 L3 F2 Earth Screw L1 Outdoor unit shows terminal block and figures show terminal numbers. Broken lines show wiring at site. Do not operate the units with the magnetic contactor pushed in. 35 N Power Supply 380/415V 3N~50Hz Symbol FM RC TR F Name Symbol Name Fan Motor Sensor TA Running Capacitor TC Sensor Transformer RY01~RY07 Relay Fuse (PCB) 3. WIRING DIAGRAMS 3.6 RAV-104TUH-PE RAV-134TUH-PE RAV-164TUH-PE TC TA DM CN12 RY03 L RY02 5 5 BLU UL 7 7 YEL 9 9 RED RY01 (output) CS BLK CN09 (WHI) (LOUVER) BLK CN21 4 3 2 1 F3 WHI CN01 (TRANS) ORG 4 BLU 3 BLK 2 YEL 1 CN07 (FAN) BLK H 1 1 M ORG 3 3 RY04 REMOCON ORG 1 1 YEL 2 2 BLU 3 3 CN02 15 15 14 14 13 13 12 12 11 11 10 10 9 9 8 8 7 7 6 6 5 5 4 4 3 3 2 2 1 1 CN05 (TC) CN04 2 2 CN15 (TA) 1 1 (LAN) GRY GRY Interface PCB 3 3 RY01 TR RY07 RY06 RED 1 1 RED CN03 (L1) (N) (SERIAL) 5 1 3 5 1 3 BLK 1 1 GRY PUR 3 3 GRY F 5 5 7 7 GRY CN10 (PUMP) RED TR SM 01 SM 02 WHI 4 6 5 1 2 3 4 6 5 1 2 3 WHI WHI RED 1 2 3 4 5 6 RC01 1 2 3 4 5 6 WHI FM 02 RED YEL BLU ORG BLK RC02 WHI RED GRN/YEL Indoor unit Y X A B 1 2 3 1 2 3 L N 1 2 3 4 5 6 1 2 3 4 5 6 WHI FM 01 RED YEL BLU ORG BLK C (1 Phase model) F2 Earth Screw X Y Central Remote Controller (Optional) A B C Remote Controller (Optional) Outdoor unit Power Supply 220/240V ~50Hz shows terminal block and figures show terminal numbers. Broken lines show wiring at site. Do not operate the units with the magnetic contactor pushed in. Symbol FM01, 02 RC01, 02 TR TA TC RY01~RY07 36 Name Fan Motor Running Capacitor Transformer Sensor Sensor Relay Symbol F F3 DM SM01, 02 CS Name Fuse (PCB) Fuse (Interface) PCB Drain Pump Stepper Motor Float Switch 3. WIRING DIAGRAMS 3.7 RAV-164UH-PE RAV-264UH-PE RAV-364UH-PE RAV-464UH-PE TC TA RED 1 1 2 2 3 3 CN02 CN12 H 1 1 M 3 3 L RY03 5 5 BLK ORG BLU UL 7 7 YEL RY02 9 9 RED 1 2 3 4 5 6 7 8 9 RED WHI GRY FM BLK ORG BLU YEL GRN/YEL RY01 (output) CN21 BLK CN09 (WHI). (LOUVER) BLK GM 4 3 2 1 WHI CN01 (TRANS) ORG 4 BLU 3 BLK 2 YEL 1 1 2 3 4 5 6 7 8 9 CN07 (FAN) RY04 REMOCON ORG YEL BLU RC CN05 (TC) CN04 CN15 (TA) (LAN) GRY GRY CN16 3 3 RY01 RY07 RY06 RED 1 1 (L1) (N) 1 3 1 3 CN03 (SERIAL) 5 5 BLK 1 1 RED 3 3 GRY GRY RED 5 5 GRY F CN10 (PUMP) 7 7 PUR TR DM Infra-Red Receiver (PGR models) CS GRN/YEL A B C 1 2 3 1 2 3 L2 L3 1 2 3 L N Indoor unit (3 Phase model) Y X A C B F2 Earth Screw L1 Outdoor unit X Y Central Remote Controller (Optional) A B N Power Supply 380/415V 3N~50Hz C Remote Controller (Not PGR models) (Optional) (1 Phase model) F2 Earth Screw Power Supply 220/240V ~50Hz shows terminal block and figures show terminal numbers. Broken lines show wiring at site. Do not operate the units with the magnetic contactor pushed in. 37 Symbol FM RC F TR DM Name Symbol Name Fan Motor TA Sensor TC Sensor Running Capacitor Geared Motor GM Fuse (PCB) RY01~RY07 Relay Transformer CS Float Switch Drain Pump 3. WIRING DIAGRAMS 3.8 RAV-134AH-PE RAV-164AH-PE RAV-264AH-PE A B 1 C 2 3 Indoor unit Outdoor unit 1 Earth Screw 2 3 TR Earth RED F2 TD RY05 F Wave Control Circuit RY07 BLK TE TL BLK WHI WHI 63H 1 1 2 2 3 3 B 9 10 11 52C 12 L BLU RED C A 6 5 4 RED 3 2 WHI GRY 1 6 5 4 RED 3 FM 2 WHI 0 1 RCo 26HD 20SF 20SR CM 52C L RCc 1 2 3 4 13 14 31 32 49C N CH Power Supply 220/240V~50Hz Shows terminal block and figures show terminal numbers. Broken lines show wiring at site. Do not operate the units with magnetic contactor pushed in. Symbol Name Symbol 20SF RY05,07 49C 20SR RCc RCo Solenoid coil (4 way valve) Relay Inner overload relay Solenoid coil (2 way valve) Running capacitor (compressor) Running capacitor (fan motor) CM 52C FMo TL TE 26HD Name Compressor Magnetic contactor Fan motor Sensor Sensor Bimetal thermostat 38 Symbol F2 63H CH F TR TD Name Fuse (T5A) High pressure switch Crankcase heater Fuse (on PCB) Transformer Sensor (Dummy) BLK 3. WIRING DIAGRAMS 3.9 RAV-264AH8-PE A B 1 C 2 3 Indoor unit Outdoor unit 1 2 3 Earth Screw TR Earth RED TD RY05 F Wave Control Circuit RY07 BLK TE TL BLK WHI WHI BLU RED 6 5 4 RED 3 2 WHI GRY 1 BLK 63H 1 1 2 2 3 3 B 9 11 10 52C 12 L C 6 5 4 RED 3 FM 2 0 WHI 1 BLK RCo A 22 26HD 51C 21 20SF F2 20SR 49C 47C S R T 47C L1 L2 L3 1 2 U 2 3 4 V 4 5 6 W 6 13 14 31 32 CM 51C N Power Supply 380-415V 3N~50Hz CH 52C 1. Shows terminal block and figures show terminal numbers. Broken lines show wiring at site. 2. When the three phases are not connected correctly, the reverse phase protector operates, and the unit will not start. In this case, check the three phase wiring. Do not operate the units with magnetic contactor pushed in. Symbol 20SF RY05,07 49C 51C 47C RCo Name Solenoid coil (4 way valve) Relay Temperature Overload relay Current Overload relay Reverse phase protector Running capacitor 20SR Solenoid coil (2-way valve) Name Symbol CM 52C FMo TL TE TD Compressor Magnetic contactor Fan motor Sensor Sensor Sensor (Dummy) 39 Symbol F2 63H CH F TR 26HD Name Fuse (T5A) High pressure switch Crankcase heater Fuse (on PCB) Transformer Bi-metal thermostat 3. WIRING DIAGRAMS 3.10 RAV-364AH8-PE RAV-464AH8-PE A B 1 C 2 3 Indoor unit Outdoor unit 1 2 3 Earth Screw TR Earth RED TD RY05 F Wave Control Circuit RY07 BLK TE TL BLK WHI WHI 6 BLK 5 4 RED 3 2 WHI GRY 1 A2 9 11 10 52C 12 BLK 6 5 4 RED 3 FM 2 WHI UP 1 RC01 A1 BLK GRY RED RC02 WHI 63H 20SF BLU RED 1 1 2 2 3 3 F2 L C 47C 6 5 4 3 2 1 6 5 4 RED 3 FM 2 WHI LOW 1 BLK 47C S R T 1 L1 L2 L3 2 3 4 5 6 13 14 21 22 CM * N Power Supply 380-415V 3N~50Hz CH 52C 1. Shows terminal block and figures show terminal numbers. Broken lines show wiring at site. 2. When the phases are not connected correctly, the reverse phase protector operates and the unit will not start. In this case, check the three phase wiring. * Compressor has internal thermal protection Do not operate the units with magnetic contactor pushed in. Symbol 20SF RY05,07 47C F2 RC01,02 Name Solenoid coil Relay Reverse Phase Protector Fuse (T5A) Running capacitor Name Symbol CM 52C FMUP,LOW TL TE Compressor Magnetic contactor Fan motor (Outdoor) Sensor Sensor 40 Symbol 63H CH F TR TD Name High pressure switch Crankcase heater Fuse (on PCB) Transformer Sensor 4. SPECIFICATIONS OF ELECTRICAL PARTS 4.1 RAV-164BH-PE No TYPE SPECIFICATIONS 1 Indoor Unit fan motor SMF-230-60-4A 2 Running capacitor for indoor fan motor EEP2G405HQA114 AC 400V, 4µF 3 Transformer (Indoor Unit) ST-10568 AC 187-264V 4 Sensor for room temperature 5 4.2 PARTS NAME Output (rated) 60W, 4 pole, 230V, 1 Phase, 50Hz Maximum input 38mA Sensor for heat exchanger temperature ûC 15 20 25 30 40 k½ 16.1 12.6 10.0 8.0 5.2 Maximum input 15.5mA ûC -12 10 k½ 67.5 21.3 RAV-264BH-PE No PARTS NAME TYPE SPECIFICATIONS 1 Indoor Unit fan motor STF-200-100-4B Output (rated) 100W, 4 pole, 200V, 1 Phase, 50Hz 2 Running capacitor for indoor fan motor EAG40M505UF AC 400V, 5µF 3 Transformer (Indoor Unit) ST-10568 AC 187-264V 4 Sensor for room temperature 5 Maximum input 38mA Sensor for heat exchanger temperature ûC 15 20 25 30 40 k½ 16.1 12.6 10.0 8.0 5.2 ûC -12 10 k½ 67.5 21.3 Maximum input 15.5mA 4.3 RAV-364BH-PE No TYPE SPECIFICATIONS 1 Indoor Unit fan motor STF-200-120-4B Output (rated) 120W, 4 pole, 200V, 1 Phase, 50Hz 2 Running capacitor for indoor fan motor EAG40M505UF AC 400V, 5µF 3 Transformer (Indoor Unit) ST-10568 AC 187-264V 4 Sensor for room temperature 5 4.4 PARTS NAME Maximum input 38mA Sensor for heat exchanger temperature ûC 15 20 25 30 40 k½ 16.1 12.6 10.0 8.0 5.2 ûC -12 10 k½ 67.5 21.3 Maximum input 15.5mA RAV464BH-PE No PARTS NAME TYPE SPECIFICATIONS 1 Indoor Unit fan motor STF-200-140-4F Output (rated) 140W, 4 pole, 200V, 1 Phase, 50Hz 2 Running capacitor for indoor fan motor EAG40M106UF AC 400V, 10µF 3 Transformer (Indoor Unit) 4 Sensor for room temperature 5 ST-10568 AC 187-264V Maximum input 38mA Sensor for heat exchanger temperature Maximum input 15.5mA 41 ûC 15 20 25 30 40 k½ 16.1 12.6 10.0 8.0 5.2 ûC -12 10 k½ 67.5 21.3 4. SPECIFICATIONS OF ELECTRICAL PARTS 4.5 RAV-134CH/CHR-PE No PARTS NAME TYPE SPECIFICATIONS Output (rated) 34W, 4 pole, 230V, 1 Phase, 50Hz 1 Indoor Unit fan motor SMF-230-34-4H 2 Running capacitor for indoor fan motor EEP2H155HQA107 3 Transformer (Indoor Unit) ST-10568 AC 187-264V 4 Geared motor MT8-3-6 AC 230V, 3W 5 Sensor for room temperature 6 AC 500V, 1.5µF Maximum input 38mA ûC 15 20 25 30 40 k½ 16.1 12.6 10.0 8.0 5.2 ûC -12 10 k½ 67.5 21.3 Maximum input 15.5mA Indoor Unit sensor for heat exchanger temperature 4.6 RAV-164CH/CHR-PE No TYPE SPECIFICATIONS Output (rated) 34W, 4 pole, 230V, 1 Phase, 50Hz 1 Indoor Unit fan motor SMF-230-34-4D 2 Running capacitor for indoor fan motor EEP2W255HQA113 3 Transformer (Indoor Unit) ST-10568 AC 187-264V 4 Geared motor MT8-3-6 AC 230V, 3W 5 Sensor for room temperature 6 4.7 PARTS NAME AC 450V, 2.5µF Maximum input 38mA ûC 15 20 25 30 40 k½ 16.1 12.6 10.0 8.0 5.2 ûC -12 10 k½ 67.5 21.3 Maximum input 15.5mA Indoor Unit sensor for heat exchanger temperature RAV-264CH/CHR-PE No PARTS NAME TYPE SPECIFICATIONS Output (rated) 34W, 4 pole, 230V, 1 Phase, 50Hz 1 Indoor Unit fan motor SMF-230-34-4D 2 Running capacitor for indoor fan motor EEP2W255HQA113 3 Transformer (Indoor Unit) ST-10568 AC 187-264V 4 Geared motor MT8-3-6 AC 230V, 3W 5 Sensor for room temperature 6 AC 450V, 2.5µF Maximum input 38mA Maximum input 15.5mA Indoor Unit sensor for heat exchanger temperature 42 ûC 15 20 25 30 40 k½ 16.1 12.6 10.0 8.0 5.2 ûC -12 10 k½ 67.5 21.3 4. SPECIFICATIONS OF ELECTRICAL PARTS 4.8 RAV-364CH/CHR-PE No PARTS NAME TYPE SPECIFICATIONS 1 Indoor Unit fan motor SMF-230-75-4U Output (rated) 75W, 4 pole, 230V, 1 Phase, 50Hz 2 Running capacitor for indoor fan motor EVM45M305UF AC 450V, 3.0µF 3 Transformer (Indoor Unit) ST-10568 AC 187-264V 4 Geared motor MT8-3-6 AC 230V, 3W 5 Sensor for room temperature 6 Maximum input 38mA ûC 15 20 25 30 40 k½ 16.1 12.6 10.0 8.0 5.2 ûC -12 10 k½ 67.5 21.3 Maximum input 15.5mA Indoor Unit sensor for heat exchanger temperature 4.9 RAV-464CH/CHR-PE No PARTS NAME TYPE SPECIFICATIONS Output (rated) 75W, 4 pole, 230V, 1 Phase, 50Hz 1 Indoor Unit fan motor SMF-230-75-4B 2 Running capacitor for indoor fan motor EEP2G405HQA114 3 Transformer (Indoor Unit) ST-10568 AC 187-264V 4 Geared motor MT8 -3-6 AC 230V, 3W 5 Sensor for room temperature 6 AC 400V, 4.0µF Maximum input 38mA Maximum input 15.5mA Indoor Unit sensor for heat exchanger temperature 43 ûC 15 20 25 30 40 k½ 16.1 12.6 10.0 8.0 5.2 ûC -12 10 k½ 67.5 21.3 4. SPECIFICATIONS OF ELECTRICAL PARTS 4.10 RAV-134KH/KHR-PE No PARTS NAME TYPE SPECIFICATIONS 1 Indoor Unit fan motor MMF-230-27-4P 2 Running capacitor for indoor fan motor EEP2H105HQA105 3 Transformer (Indoor Unit) ST-10568 AC 187-264V 4 Geared motor MT8-3-6 AC 230V, 3W 5 Sensor for room temperature 6 Output (rated) 27W, 4 pole, 230V, 1 Phase, 50Hz AC 500V, 1.0µF Maximum input 38mA ûC 15 20 25 30 40 k½ 16.1 12.6 10.0 8.0 5.2 ûC -12 10 k½ 67.5 21.3 Maximum input 15.5mA Indoor Unit sensor for heat exchanger temperature 4.11 RAV-164KH/KHR-PE No PARTS NAME TYPE SPECIFICATIONS Output (rated) 27W, 4 pole, 230V, 1 Phase, 50Hz 1 Indoor Unit fan motor MMF-230-27-4P 2 Running capacitor for indoor fan motor EEP2H155HQA107 3 Transformer (Indoor Unit) ST-10568 AC 187-264V 4 Geared motor MT8-3-6 AC 230V, 3W 5 Sensor for room temperature 6 AC 500V, 1.5µF Maximum input 38mA ûC 15 20 25 30 40 k½ 16.1 12.6 10.0 8.0 5.2 Maximum input 15.5mA Indoor Unit sensor for heat exchanger temperature ûC -12 10 k½ 67.5 21.3 4.12 RAV-264KH/KHR-PE No PARTS NAME TYPE SPECIFICATIONS Output (rated) 27W, 4 pole, 230V, 1 Phase, 50Hz 1 Indoor Unit fan motor MMF-230-27-4R 2 Running capacitor for indoor fan motor EEP2W205HQA107 3 Transformer (Indoor Unit) ST-10568 AC 187-264V 4 Geared motor MT8-3-6 AC 230V, 3W 5 Sensor for room temperature 6 AC 450V, 2.0µF Maximum input 38mA Maximum input 15.5mA Indoor Unit sensor for heat exchanger temperature 44 ûC 15 20 25 30 40 k½ 16.1 12.6 10.0 8.0 5.2 ûC -12 10 k½ 67.5 21.3 4. SPECIFICATIONS OF ELECTRICAL PARTS 4.13 RAV-104NH-PE No PARTS NAME TYPE SPECIFICATIONS 1 Indoor Unit fan motor SMF-230-34-4H 2 Running capacitor for indoor fan motor EEP2H155HQA107 3 Transformer (Indoor Unit) 4 Sensor for room temperature 5 Output (rated) 34W, 4 pole, 230V, 1 Phase, 50Hz ST-10568 AC 500V, 1.5µF AC 187-264V Maximum input 38mA Sensor for heat exchanger temperature ûC 15 20 25 30 40 k½ 16.1 12.6 10.0 8.0 5.2 ûC -12 10 k½ 67.5 21.3 Maximum input 15.5mA 4.14 RAV-134NH-PE No PARTS NAME TYPE SPECIFICATIONS 1 Indoor Unit fan motor SMF-230-34-4H 2 Running capacitor for indoor fan motor EEP2W205HQA107 AC 450V, 2µF 3 Transformer (Indoor Unit) ST-10568 AC 187-264V 4 Sensor for room temperature 5 Output (rated) 34W, 4 pole, 230V, 1 Phase, 50Hz Maximum input 38mA Sensor for heat exchanger temperature ûC 15 20 25 30 40 k½ 16.1 12.6 10.0 8.0 5.2 Maximum input 15.5mA ûC -12 10 k½ 67.5 21.3 4.15 RAV-164NH-PE No PARTS NAME TYPE SPECIFICATIONS 1 Indoor Unit fan motor SMF-230-34-4E 2 Running capacitor for indoor fan motor EEP2W255HQA113 3 Transformer (Indoor Unit) 4 Sensor for room temperature 5 Output (rated) 34W, 4 pole, 230V, 1 Phase, 50Hz ST-10568 AC 450V, 2,5µF AC 187-264V Maximum input 38mA Sensor for heat exchanger temperature ûC 15 20 25 30 40 k½ 16.1 12.6 10.0 8.0 5.2 ûC -12 10 k½ 67.5 21.3 Maximum input 15.5mA 4.16 RAV-264NH-PE No PARTS NAME TYPE SPECIFICATIONS 1 Indoor Unit fan motor SMF-230-34-40 2 Running capacitor for indoor fan motor EEP2H155HQA107 3 Transformer (Indoor Unit) 4 Sensor for room temperature 5 Output (rated) 34W, 4 pole, 230V, 1 Phase, 50Hz ST-10568 AC 500V, 1.5µF AC 187-264V Maximum input 38mA Sensor for heat exchanger temperature Maximum input 15.5mA 45 ûC 15 20 25 30 40 k½ 16.1 12.6 10.0 8.0 5.2 ûC -12 10 k½ 67.5 21.3 4. SPECIFICATIONS OF ELECTRICAL PARTS 4.17 RAV-164SH/SHR-PE No PARTS NAME TYPE SPECIFICATIONS 1 Indoor Unit fan motor SMF-230-34-4D 2 Running capacitor for indoor fan motor EEP2W255HQA113 3 Transformer (Indoor Unit) 4 Sensor for room temperature 5 Output (rated) 34W, 4 pole, 230V, 1 Phase, 50Hz ST-10568 AC 450V, 2.5µF AC 187-264V Maximum input 38mA Sensor for heat exchanger temperature ûC 15 20 25 30 40 k½ 16.1 12.6 10.0 8.0 5.2 Maximum input 15.5mA ûC -12 10 k½ 67.5 21.3 4.18 RAV-264SH/SHR-PE No PARTS NAME TYPE SPECIFICATIONS 1 Indoor Unit fan motor SMF-230-34-4D 2 Running capacitor for indoor fan motor EEP2W255HQA113 3 Transformer (Indoor Unit) 4 Sensor for room temperature 5 Output (rated) 34W, 4 pole, 230V, 1 Phase, 50Hz ST-10568 AC 450V, 2.5µF AC 187-264V Maximum input 38mA Sensor for heat exchanger temperature Maximum input 15.5mA 46 ûC 15 20 25 30 40 k½ 16.1 12.6 10.0 8.0 5.2 ûC -12 10 k½ 67.5 21.3 4. SPECIFICATIONS OF ELECTRICAL PARTS 4.19 RAV-104TUH-PE No PARTS NAME TYPE SPECIFICATIONS Output (rated) 7W, 4 pole, 230V, 1 Phase, 50Hz 1 Indoor unit fan motor (x2) 2 Running capacitor for indoor fan motor (x2) 3 Transformer (Indoor Unit) ST-10568 AC 187-264V 4 Stepper motor (x2) MP35EA2 DC 12V, 80mNm 5 Drain pump PCD-4N230TF-3 AC 230V, 0.2A 6 Float switch FS-085-003E AC 230V, 0.5A 7 Sensor for room temperature 8 PAF-230-7-4 AC 450V, 0.5µF EVM45M504UF Maximum input 38mA ûC 15 20 25 30 40 k½ 16.1 12.6 10.0 8.0 5.2 Maximum input 15.5mA Indoor Unit sensor for heat exchanger temperature ûC -12 10 k½ 67.5 21.3 4.20 RAV-134TUH-PE No PARTS NAME TYPE SPECIFICATIONS Output (rated) 7W, 4 pole, 230V, 1 Phase, 50Hz 1 Indoor unit fan motor (x2) 2 Running capacitor for indoor fan motor (x2) 3 Transformer (Indoor Unit) ST-10568 AC 187-264V 4 Stepper motor (x2) MP35EA2 DC 12V, 80mNm 5 Drain pump PCD-4N230TF-3 AC 230V, 0.2A 6 Float switch FS-085-003E AC 230V, 0.5A 7 Sensor for room temperature 8 PAF-230-7-4 EEP2H105HQA105 AC 500V, 1.0µF Maximum input 38mA ûC 15 20 25 30 40 k½ 16.1 12.6 10.0 8.0 5.2 Maximum input 15.5mA Indoor Unit sensor for heat exchanger temperature ûC -12 10 k½ 67.5 21.3 4.21 RAV-164TUH-PE No PARTS NAME TYPE SPECIFICATIONS Output (rated) 7W, 4 pole, 230V, 1 Phase, 50Hz 1 Indoor unit fan motor (x2) 2 Running capacitor for indoor fan motor (x2) 3 Transformer (Indoor Unit) ST-10568 AC 187-254V 4 Stepper motor (x2) MP35EA2 DC 12V, 80mNm 5 Drain pump PCD-4N230TF-3 AC 230V, 0.2A 6 Float switch FS-085-003E AC 230V, 0.5A 7 Sensor for room temperature 8 PAF-230-7-4 EEP2H105HQA105 AC 500V, 1.0µF Maximum input 38mA Maximum input 15.5mA Indoor Unit sensor for heat exchanger temperature 47 ûC 15 20 25 30 40 k½ 16.1 12.6 10.0 8.0 5.2 ûC -12 10 k½ 67.5 21.3 4. SPECIFICATIONS OF ELECTRICAL PARTS 4.22 RAV-164UH-PE No TYPE SPECIFICATIONS Output (rated) 28W, 6 pole, 230V, 1 Phase, 50Hz 1 Indoor unit fan motor MMF-230-28A 2 Running capacitor for indoor fan motor EEP2H105HQA105 3 Transformer (Indoor Unit) ST-10568 AC 287-264V 4 Geared motor MT8-3-8 AC 240V, 3W 5 Drain pump PJV-0739 AC 230V, 0.2A 6 Float switch FS-085-003B AC 230V, 0.5A 7 Sensor for room temperature 8 4.23 PARTS NAME AC 500V, 1.0µF Maximum input 38mA ûC 15 20 25 30 40 k½ 16.1 12.6 10.0 8.0 5.2 ûC -12 10 k½ 67.5 21.3 Maximum input 15.5mA Indoor Unit sensor for heat exchanger temperature RAV-264UH-PE No PARTS NAME TYPE SPECIFICATIONS Output (rated) 28W, 6 pole, 230V, 1 Phase, 50Hz 1 Indoor unit fan motor MMF-230-28A 2 Running capacitor for indoor fan motor EEP2W205HQA107 3 Transformer (Indoor Unit) ST-10568 AC 187-264V 4 Geared motor MT8-3-8 AC 240V, 3W 5 Drain pump PJV-0739 AC 230V, 0.2A 6 Float switch FS-085-003B AC 230V, 0.5A 7 Sensor for room temperature 8 AC 450V, 2.0µF Maximum input 38mA Maximum input 15.5mA Indoor Unit sensor for heat exchanger temperature 48 ûC 15 20 25 30 40 k½ 16.1 12.6 10.0 8.0 5.2 ûC -12 10 k½ 67.5 21.3 4. SPECIFICATIONS OF ELECTRICAL PARTS 4.24 RAV-364UH-PE No TYPE SPECIFICATIONS 1 Indoor unit fan motor MMF-230-36A 2 Running capacitor for indoor fan motor EEP2W255HQA113 3 Transformer (Indoor Unit) ST-10568 AC 187-264V 4 Geared motor MT8-3-8 AC 230V, 3W 5 Drain pump PJV-0739 AC 230V, 0.2A 6 Float switch FS-085-003B AC 230V, 0.5A 7 Sensor for room temperature 8 4.25 PARTS NAME Output (rated) 36W, 6 pole, 230V, 1 Phase, 50Hz AC 450V, 2.5µF Maximum input 38mA Indoor Unit sensor for heat exchanger temperature ûC 15 20 25 30 40 k½ 16.1 12.6 10.0 8.0 5.2 ûC -12 10 k½ 67.5 21.3 Maximum input 15.5mA RAV-464UH-PE No PARTS NAME TYPE SPECIFICATIONS 1 Indoor unit fan motor MMF-230-36A 2 Running capacitor for indoor fan motor EVM45M305UF 3 Transformer (Indoor Unit) ST-10568 AC 187-264V 4 Geared motor MT8-3-8 AC 230V, 3W 5 Drain pump PJV-0739 AC 230V, 0.2A 6 Float switch FS-085-003B AC 230V, 0.5A 7 Sensor for room temperature 8 Output (rated) 36W, 6 pole, 230V, 1 Phase, 50Hz AC 450V, 3.0µF Maximum input 38mA Indoor Unit sensor for heat exchanger temperature Maximum input 15.5mA 49 ûC 15 20 25 30 40 k½ 16.1 12.6 10.0 8.0 5.2 ûC -12 10 k½ 67.5 21.3 4. SPECIFICATIONS OF ELECTRICAL PARTS 4.26 RAV-134AH-PE No PARTS NAME TYPE SPECIFICATIONS 1 Compressor PG330X3F-4LS Output (rated) 1.5kW, 2 pole, 220/240V, 1 Phase, 50Hz 2 Outdoor unit fan motor SMF-230-39N-2 Output (rated) 39W, 6 pole, 230V, 1 Phase, 50Hz 3 Running capacitor for outdoor fan motor EEP2G405HQA114 4 Magnetic contactor FMCa-1S-02 AC 220-240V, 50Hz 5 High pressure switch ACB-2TB04W Tripping pressure 30kgf/cm2G Resetting pressure 23kgf/cm2G 6 Solenoid coil for four-way valve CHV-AC240V AC 220-240V 7 Crankcase heater AC 240V, 28W 8 Sensor for defrosting Maximum input 15.5mA AC 400V, 4µF 9 Fuse T5A 10 Sensor for cooling operation in low ambient temperature Maximum input 15.5mA 11 Solenoid coil for two-way valve NEV AC 240V AC 220-240V, 50Hz 12 Running capacitor for compressor MT-44MP456W AC 440V, 45µF 13 Transformer (Outdoor Unit) 14 Bimetal thermostat AC 187-264V FT-67 Tripping temperature: 110ûC Resetting temperature: 90ûC CS-12A 50 ûC -12 10 k½ 67.5 21.3 ûC -12 10 k½ 67.5 21.3 4. SPECIFICATIONS OF ELECTRICAL PARTS 4.27 RAV-164AH-PE No PARTS NAME TYPE SPECIFICATIONS 1 Compressor PG350X3F-4LS Output (rated) 1.5kW, 2 pole, 220/240V, 1 Phase, 50Hz 2 Outdoor unit fan motor SMF-230-39N-2 Output (rated) 39W, 6 pole, 230V, 1 Phase, 50Hz 3 Running capacitor for outdoor fan motor EEP2G405HQA114 4 Magnetic contactor FMCa-1S-02 AC 220-240V, 50Hz 5 High pressure switch ACB-2TB04W Tripping pressure 30kgf/cm2G Resetting pressure 23kgf/cm2G 6 Solenoid coil for four-way valve CHV-AC240V AC 220-240V 7 Crankcase heater AC 240V, 28W 8 Sensor for defrosting Maximum input 15.5mA AC 400V, 4µF 9 Fuse T5A 10 Sensor for cooling operation in low ambient temperature Maximum input 15.5mA 11 Solenoid coil for two-way valve NEV AC 240V AC 220-240V, 50Hz 12 Running capacitor for compressor MT-44MP456W AC 440V, 45µF 13 Transformer (Outdoor Unit) 14 Bimetal thermostat AC 187-264V FT-67 Tripping temperature: 110ûC Resetting temperature: 90ûC CS-12A 51 ûC -12 10 k½ 67.5 21.3 ûC -12 10 k½ 67.5 21.3 4. SPECIFICATIONS OF ELECTRICAL PARTS 4.28 RAV-264AH-PE No PARTS NAME TYPE SPECIFICATIONS 1 Compressor PG460X3F-4MS Output (rated) 2.2kW, 2 pole, 220/240V, 1 Phase, 50Hz 2 Outdoor unit fan motor SMF-230-63N-2 Output (rated) 63W, 6 pole, 230V, 1 Phase, 50Hz 3 Running capacitor for outdoor fan motor EEP2G405HQA114 4 Magnetic contactor FMCa-1S-02 AC 220-240V, 50Hz 5 High pressure switch ACB-2TB04W Tripping pressure 30kgf/cm2G Resetting pressure 23kgf/cm2G 6 Solenoid coil for four-way valve CHV-AC240V AC 220-240V 7 Crankcase heater AC 240V, 28W 8 Sensor for defrosting Maximum input 15.5mA 9 Fuse T5A 10 Sensor for cooling operation in low ambient temperature Maximum input 15.5mA 11 Solenoid coil for two-way valve 12 Running capacitor for compressor 13 Transformer (Outdoor Unit) 14 Bimetal thermostat AC 400V, 4µF ûC -12 10 k½ 67.5 21.3 ûC -12 10 k½ 67.5 21.3 AC 220-240V, 50Hz NEV AC 240V AC 420V, 60µF EAR42M606UF AC 187-264V FT-67 Tripping temperature: 110ûC CS-12A 52 Resetting temperature: 90ûC 4. SPECIFICATIONS OF ELECTRICAL PARTS 4.29 RAV-264AH8-PE No PARTS NAME TYPE SPECIFICATIONS 1 Compressor YG460X3F-MS Output (rated) 2.2kW, 2 pole, 380/415V, 3 Phase, 50Hz 2 Outdoor unit fan motor SMF-230-63N-2 Output (rated) 63W, 6 pole, 230V, 1 Phase, 50Hz 3 Running capacitor for outdoor fan motor EEP2G405HQA114 4 Magnetic contactor 5 High pressure switch ACB-2TB04W Tripping pressure 30kgf/cm2G Resetting pressure 23kgf/cm2G 6 Solenoid coil for four-way valve CHV-AC240V AC 220-240V 7 Crankcase heater AC 240V, 28W 8 Sensor for defrosting Maximum input 15.5mA 9 Fuse T5A 10 Sensor for cooling operation in low ambient temperature Maximum input 15.5mA AC 220-240V, 50Hz FMSa-1 11 Solenoid coil for two-way valve NEV AC 240V 12 Reverse Phase Protector STR-4AD 13 Transformer (Outdoor Unit) 14 Bimetal thermostat AC 400V, 4µF ûC -12 10 k½ 67.5 21.3 ûC -12 10 k½ 67.5 21.3 AC 220-240V, 50Hz AC 187-264V FT-67 Tripping temperature: 110ûC CS-12A 53 Resetting temperature: 90ûC 4. SPECIFICATIONS OF ELECTRICAL PARTS 4.30 RAV-364AH8-PE No 1 PARTS NAME Compressor TYPE SPECIFICATIONS ZR49KCE-TFD-230 Output (rated) 3.0kW, 2 pole, 380/415V, 3 Phase, 50Hz Winding resistance 3.73½ at 20ûC 2 Outdoor unit fan motor SMF-230-63N-2 Output (rated) 63W, 6 pole, 230V, 1 Phase, 50Hz SMF-230-39N-2 Output (rated) 39W, 6 pole, 230V, 1 Phase, 50Hz EEP2G405HQA114 AC 400V, 4µF FC-2S AC 230V, 50Hz 3 Running capacitor for outdoor fan motor 4 Magnetic contactor 5 High pressure switch ACB-2TB04W Tripping pressure 30kgf/cm2G Resetting pressure 23kgf/cm2G 6 Solenoid coil CHV-AC240V AC 220-240V 7 Crankcase heater AC 240V, 28W 8 Outdoor unit for heat exchanger temperature Maximum input 15.5mA Transformer for outdoor unit 10 Fuse T5A 11 Sensor for cooling operation in low ambient temperature Maximum input 15.5mA Reverse Phase Protector 13 Sensor for delivery pipe temperature -12 10 k½ 67.5 21.3 AC 187-264V 9 12 ûC FT-67 ûC -12 10 k½ 67.5 21.3 ûC 23 100 k½ 57.0 3.4 STR-4AD 54 4. SPECIFICATIONS OF ELECTRICAL PARTS 4.31 RAV-464AH8-PE No 1 PARTS NAME Compressor TYPE SPECIFICATIONS ZR61KCE-TFD-230 Output (rated) 3.75kW, 2 pole, 380/415V, 3 Phase, 50Hz Winding resistance 2.19 ½ at 20ûC 2 Outdoor unit fan motor SMF-230-63N-2 Output (rated) 63W, 6 pole, 230V, 1 Phase, 50Hz SMF-230-39N-2 Output (rated) 39W, 6 pole, 230V, 1 Phase, 50Hz EEP2G405HQA114 AC 400V, 4µF FC-2S AC 230V, 50Hz 3 Running capacitor for outdoor fan motor 4 Magnetic contactor 5 High pressure switch ACB-2TB04W Tripping pressure 30kgf/cm2G Resetting pressure 23kgf/cm2G 6 Solenoid coil CHV-AC240V AC 220-240V 7 Crankcase heater AC 240V, 28W 8 Outdoor unit for heat exchanger temperature Maximum input 15.5mA Transformer for outdoor unit 10 Fuse T5A 11 Sensor for cooling operation in low ambient temperature Maximum input 15.5mA Reverse Phase Protector 13 Sensor for delivery pipe temperature -12 10 67.5 21.3 ûC -12 10 k½ 67.5 21.3 ûC 23 100 k½ 57.0 3.4 AC 187-264V 9 12 ûC k½ FT-67 STR-4AD 55 5. REFRIGERANT PIPING DIAGRAMS 5.1 Indoor Unit RAV-104NH-PE RAV-104TUH-PE Cooling Heating Indoor unit Heat exchanger Distributor strainer Capillary tube Strainer TC Sensor Refrigerant pipe (Gas) ¿12.7mm (1/2") Refrigerant pipe (Liquid) ¿6.4mm (1/4") Capillary Model RAV-104NH-PE ID¿1.7x250Lx2P RAV-104TUH-PE ID¿2.4x300Lx2P 56 5. REFRIGERANT PIPING DIAGRAMS 5.2 Indoor Unit RAV-134CH/CHR-PE RAV-134KH/KHR-PE RAV-134NH-PE RAV-134TUH-PE Outdoor Unit RAV-134AH-PE Cooling Heating Indoor unit Distributor strainer capillary tube Liquid tank on x2 CH/CHR and TUH only Heat exchanger Strainer TC Sensor Refrigerant pipe (Gas) ¿12.7mm (1/2") Refrigerant pipe (Liquid) ¿6.4mm (1/4") Packed valve Packed valve P2 Line pressure Strainer Cooling Liquid receiver Capillary tube ¿2.6x400Lx1P Heating P1 High pressure Low pressure Low pressure High pressure P2 Capillary tube ¿3.0x600Lx1P Dryer 2-way valve Expansion valve Heat exchanger TL sensor Check valve Distributor TE sensor Check joint P1 Capillary tube ¿0.8x1000Lx1P Strainer Four-way valve High pressure switch Accumulator Compressor Outdoor unit INDOOR UNIT Model RAV-134CH/CHR-PE RAV-134KH/KHR-PE Capillary Model ID¿2.0x300Lx2P ID¿2.0x200Lx2P ID¿1.7x300Lx2P ID¿1.7x400Lx2P RAV-134AH-PE RAV-134NH-PE ID¿1.7x150Lx3P RAV-134TUH-PE ID¿2.4x300Lx2P OUTDOOR UNIT Bypass Main Capillary Capillary ID¿2.6x400Lx1P 57 ID¿0.8x1000Lx1P Cooling Bypass Capillary ID¿3x600Lx1P 5. REFRIGERANT PIPING DIAGRAMS 5.3 Indoor Unit RAV-164BH-PE RAV-164CH/CHR-PE RAV-164KH/KHR-PE RAV-164NH-PE RAV-164SH/SHR-PE RAV-164TUH-PE RAV-164UH-PE Outdoor Unit RAV-164AH-PE Cooling Heating Indoor unit Heat exchanger Distributor strainer capillary tube Strainer TC Sensor Refrigerant pipe (Gas) ¿12.7mm (1/2") Refrigerant pipe (Liquid) ¿6.4mm (1/4") Packed valve Packed valve P2 Line pressure Strainer Cooling Liquid receiver Capillary tube ¿2.6x400Lx1P Heating P1 High pressure Low pressure Low pressure High pressure P2 Capillary tube ¿3.0x600Lx1P Dryer 2-way valve Expansion valve Heat exchanger TL sensor Check valve Distributor TE sensor Check joint P1 Capillary tube ¿0.8x1000Lx1P Strainer Four-way valve High pressure switch Accumulator Compressor Outdoor unit INDOOR UNIT Model RAV-164BH-PE RAV-164CH/CHR-PE RAV-164KH/KHR-PE RAV-164NH-PE RAV-164SH/SHR-PE RAV-164TUH-PE RAV-164UH-PE Capillary ID¿1.7x150Lx2P ID¿1.7x300Lx1P ID¿1.7x300Lx2P ID¿1.7x400Lx2P ID¿1.7x300Lx2P ID¿1.7x300Lx2P ID¿1.7x200Lx3P ID¿1.7x300Lx1P ID¿1.7x400Lx2P ID¿1.7x250Lx2P ID¿2.2x200Lx2P ID¿2.0x200Lx3P OUTDOOR UNIT Main Bypass Capillary Capillary Model RAV-164AH-PE ID¿2.6x400Lx1P 58 ID¿0.8x1000Lx1P Cooling Bypass Capillary ID¿3x600Lx1P 5. REFRIGERANT PIPING DIAGRAMS Outdoor Unit 5.4 Indoor Unit RAV-264AH-PE RAV-264BH-PE RAV-264AH8-PE RAV-264CH/CHR-PE RAV-264KH/KHR-PE RAV-264NH-PE RAV-264SH/SHR-PE RAV-264UH-PE Liquid tank on x1 CH, CHR x3 NH only Cooling Heating Indoor unit Distributor strainer capillary tube Heat exchanger Strainer TC Sensor Refrigerant pipe (Liquid) ¿9.5mm (3/8") Refrigerant pipe (Gas) ¿15.9mm (5/8") Packed valve Packed valve P2 Line pressure Strainer Cooling Low pressure Low pressure High pressure P2 Capillary tube ¿2.6mm x 300L x 1P Check valve Heating P1 High pressure Dryer 2-way valve Expansion valve Heat exchanger Check valve TL sensor Distributor TE sensor Check joint P1 Strainer Bypass Capillary Strainer Four-way valve High pressure switch Accumulator Compressor Outdoor unit INDOOR UNIT MODEL RAV-264CH/CHR-PE RAV-264UH-PE RAV-264BH-PE RAV-264KH/KHR-PE RAV-264NH-PE RAV-264SH/SHR-PE OUTDOOR UNIT CAPILLARY MODEL ID¿2.6x200x4P ID¿2.6x600x2P ID¿2.6x200x5P ID¿2.6x400x1P ID¿2.6x200x4P ID¿2.6x400x2P ID¿2.6x600x4P ID¿2.6x400x2P ID¿2.6x200x5P ID¿2.6x400x1P ID¿2.6x200x4P ID¿2.6x600x2P RAV-264AH-PE RAV-264AH8-PE 59 MAIN CAPILLARY ID¿2.6x300Lx1P BYPASS CAPILLARY ID¿1.0x500Lx1P 5. REFRIGERANT PIPING DIAGRAMS Outdoor Unit 5.5 Indoor Unit RAV-364AH8-PE RAV-364BH-PE RAV-364CH/CHR-PE RAV-364UH-PE Cooling Heating Indoor unit Liquid tank on x2 CH,CHR x3 UH only Heat exchanger Distributor strainer capillary tube Strainer TC Sensor Refrigerant pipe (Gas) ¿19mm (3/4") Refrigerant pipe (Liquid) ¿9.5mm (3/8") Packed valve Packed valve P2 Line pressure Strainer Cooling Low pressure Low pressure High pressure P2 Liquid receiver Heating P1 High pressure Muffler X2 Dryer Capillary tube Expansion valve Check valve Heat exchanger TL sensor Distributor TE sensor Check joint P1 Strainer Accumulator Four-way valve High pressure switch TD Sensor Compressor Outdoor unit INDOOR UNIT MODEL RAV-364BH-PE RAV-364CH/CHR-PE CAPILLARY MODEL MAIN CAPILLARY ID¿2.2x200Lx6P ID¿2x200Lx7P ID¿2.6x200Lx6P RAV-364UH-PE OUTDOOR UNIT RAV-364AH8-PE ID¿2.6x300Lx2P ID¿2.6x500Lx2P 60 ID¿2.5x500Lx1P 5. REFRIGERANT PIPING DIAGRAMS Outdoor unit RAV-464AH8-PE 5.6 Indoor unit RAV-464BH-PE RAV-464CH-PE RAV-464UH-PE Cooling Heating Indoor unit Liquid tank on x3 CH,CHR x4 UH only Heat exchanger Distributor strainer capillary tube Strainer TC Sensor Refrigerant pipe (Gas) ø19mm (3/4²) Refrigerant pipe (Liquid) ø9.5mm (3/8²) Packed valve Packed valve P2 Line pressure Strainer Cooling Low pressure Low pressure High pressure P2 Liquid Tank Heating P1 High pressure Muffler X2 Capillary tube Dryer Expansion valve Heat exchanger Check valve TL sensor Distributor TE sensor Check joint P1 Strainer Accumulator Four-way valve High pressure switch TD Sensor Compressor Outdoor unit INDOOR UNIT MODEL OUTDOOR UNIT CAPILLARY RAV-464BH-PE IDø2.2x200Lx6P RAV-464CH/CHR-PE IDø2x200Lx8P IDø2.6x200Lx6P RAV-464UH-PE IDø2.6x300Lx2P IDø2.6x500Lx2P 61 MODEL MAIN CAPILLARY RAV-464AH8-PE IDø3x600Lx1P 6. PERFORMANCE CHARACTERISTICS 6.1 Cooling capacity Ambient Temp. (Dry Bulb) (¡C) Capacity Ratio (%) (kW) RAV-264AH-PE RAV-364AH8-PE RAV-464AH8-PE RAV-264AH8-PE RAV-134AH-PE RAV-164AH-PE 2.88 3.60 5.68 8.00 10.00 3.06 3.82 6.04 8.50 10.63 3.24 4.05 6.39 9.00 11.25 3.42 4.28 6.75 9.50 11.88 3.60 4.50 7.10 10.00 12.50 3.78 4.73 7.46 10.50 13.13 3.96 4.95 7.81 11.00 13.75 4.14 5.18 8.17 11.50 14.38 4.32 5.40 8.52 12.00 15.00 Room Temp. (Wet Bulb) (¡C) 6.2 Heating capacity (kW) RAV-134AH-PE RAV-164AH-PE 5.04 6.00 9.48 12.96 16.56 4.83 5.75 9.09 12.42 15.87 4.62 5.50 8.69 11.88 15.18 4.41 5.25 8.30 11.34 14.49 4.20 5.00 7.90 10.80 13.80 3.99 4.75 7.51 10.26 13.11 3.78 4.50 7.11 9.72 12.42 3.57 4.25 6.72 9.18 11.73 3.36 4.00 6.32 8.64 11.03 3.15 3.75 5.93 8.10 10.35 2.94 3.50 5.53 7.56 9.66 2.73 3.25 5.14 7.02 8.97 2.52 3.00 4.74 6.48 8.28 2.31 2.75 4.35 5.94 7.59 Capacity Ratio (%) Ambient Temp. (Wet Bulb) (¡C) RAV-264AH-PE RAV-364AH8-PE RAV-464AH8-PE RAV-264AH8-PE Room Temp. (Dry Bulb) (¡C) 62 6. PERFORMANCE CHARACTERISTICS 6.3 Capacity Correction Factors RAV-134AH-PE RAV-164AH-PE RAV-264AH-PE RAV-264AH8-PE Heating Capacity Ratio Outdoor Unit Height H (m) Outdoor Unit Height H (m) Cooling Capacity Ratio H INDOOR UNIT Piping Length (m) Piping Length (m) 6.4 Capacity Correction Factors RAV-364AH8-PE RAV-464AH8-PE Heating Capacity Ratio Cooling Capacity Ratio Outdoor Unit Height H (m) Outdoor Unit Height H (m) L Piping Length (m) Piping Length (m) The broken line shows in case the piping length is 30m or less 63 6. PERFORMANCE CHARACTERISTICS 6.5 Piping Length/Additional Refrigerant Volume ! The amount of refrigerant put into the outdoor unit at the factory is sufficient to fill up to 20m of refrigerant pipework. ! If the length of the refrigerant pipework is 20m or less, addition of refrigerant at the installation site is unnecessary. ! If the length of the pipework exceeds 20m, extra refrigerant must be added. Refer to the table below for details of the extra amounts. ! Overcharge or undercharge of refrigerant in the outdoor unit will cause malfunction of the compressor. The prescribed amount of the replenishment of the refrigerant is shown in the table below: Additional amount of refrigerant to add at installation site (kg)±50g Less than 5m Less Less than than 20m 25m Ñ 0.79 1.05 1.23 1.4 Ñ Ñ Ñ Ñ Ñ 0.94 1.2 1.38 1.55 Ñ Ñ Ñ Ñ Ñ Ñ 1.64 1.9 2.08 2.25 Ñ Ñ Ñ Ñ 0.88 1.05 2.44 2.7 2.88 3.05 3.23 3.4 3.58 3.75 1.25 1.5 3.13 3.5 3.75 4.0 4.25 4.5 4.75 5.0 Ñ Ñ Ñ 0.79 1.05 1.23 1.4 Ñ Ñ Ñ Ñ Ñ Ñ Ñ 0.94 1.2 1.38 1.55 Ñ Ñ Ñ Ñ Ñ Ñ 1.64 1.9 2.08 2.25 Ñ Ñ Ñ Ñ 0.88 1.05 2.44 2.7 2.88 3.05 3.23 3.4 3.58 3.75 1.5 3.13 3.5 3.75 4.0 4.25 4.5 4.75 5.0 Less than 30m Less Less than than 35m 40m 134AH-PE 0.18 0.35 Ñ Ñ Ñ 164AH-PE 0.18 0.35 Ñ Ñ Ñ 0.18 Filled 0.18 at Factory 0.25 0.35 Ñ Ñ 0.35 0.53 0.7 0.5 0.75 1.0 134A-PE 0.18 0.35 Ñ 164A-PE 0.18 0.35 Ñ 264A/A8-PE 0.18 0.35 Ñ Ñ 364A8-PE 0.18 0.35 0.53 0.7 464A8-PE 0.25 0.5 0.75 1.0 1.25 264AH/AH8-PE 364AH8-PE 464AH8-PE Less than 20m Less Less than than 45m 50m Less than 25m MODEL (RAV-) ! Recharge amount if unit is reclaimed (kg)±50g Less than 30m ADD ONLY R407C REFRIGERANT TO THESE UNITS 64 Less than 35m Less than 40m Less than 45m Less than 50m 7. EXPLODED VIEWS AND PARTS LISTS Indoor Unit Unit 7.1 Indoor RAV-164BH-PE RAV-164BH-PE RAV-264BH-PE RAV-364BH-PE RAV-264BH-PE RAV-464BH-PE RAV-364BH-PE RAV-464BH-PE 214 218 216 204 208 203 215 209 211 205 206 212 207 210 202 213 201 217 Ref No. Part No. 201 Description Model Ref No. Part No. Description Model 43160394 Connector-9P All 208 43155096 MF Capacitor 5mF 400V RAV-264/364BH-PE 202 43107215 Sensor Holder All 208 43155097 MF Capacitor 10mF 400V RAV-464BH-PE 203 43120149 Fan-Multi Blade All 209 43A58004 Transformer Ð AI All 204 43A21009 Fan Motor SMF-230-60-4A RAV-164BH-PE 210 43A60010 Terminal Block Ð ÔABCXYÕ All 204 43121516 Fan Motor STF-200-100-4B RAV-264BH-PE 211 43A60001 Terminal Block Ð Ô123Õ All 204 43121528 Fan Motor STF-200-120-4B RAV-364BH-PE 212 43A69010 PC Board Ð AI All 204 43121535 Fan Motor STF-200-140-4F RAV-464BH-PE 213 43A72004 Drain Pan Assembly RAV-164BH-PE 205 43A44031 Refrigeration Asm RAV-164BH-PE 213 43A72005 Drain Pan Assembly RAV-264BH-PE 205 RAV-364/464BH-PE 43A44032 Refrigeration Asm RAV-264BH-PE 213 43191310 Drain Pan Assembly 205 43A44039 Refrigeration Asm RAV-364BH-PE 214 43125135 Bearing RAV-464BH-PE 205 RAV-464BH-PE 215 43A60009 Bushing All All 216 43A88011 Owners Manual All All 217 43A70002 Drain Socket RAV-164BH-PE 218 43125137 Coupling 43A44040 Refrigeration Asm 206 43A50003 Sensor-Room Temp 207 43A50004 Sensor-H/Exchanger 208 43155080 MF Capacitor 4mF 400V 65 All RAV-464BH-PE 7. EXPLODED VIEWS AND PARTS LISTS 7.2 Indoor Unit RAV-134CH/CHR-PE Indoor Unit RAV-134CH/CHR-PE RAV-164CH/CHR-PE RAV-164CH/CHR-PE RAV-264CH/CHR-PE RAV-264CH/CHR-PE RAV-364CH/CHR-PE RAV-364CH/CHR-PE RAV-464CH/CHR-PE RAV-464CH/CHR-PE 211 244 206 231 203 205 209 204 234 235 223 224 220 237 238 216 230 217 215 214 226 218 240 239 219 225 232 229 233 228 206 227 242/243 207 241 213 Ref No. 201 202 203 204 205 206 207 208 209 209 209 209 210 211 212 213 214 214 215 215 215 215 216 217 218 218 218 218 219 219 220 220 221 222 223 223 223 223 Part No. 43107214 43107215 43107216 43107223 43107222 43107224 43109321 43109322 43109324 43109320 43109327 43109328 43109329 43119373 43119393 43119394 43120172 43120174 43A21013 43A21005 43A21007 43A21006 43125131 43125142 43125143 43125141 43125145 43125144 43126127 43126129 43126128 43126130 43A39004 43A39005 43A44037 43A44038 43A44054 43A44030 222 Description 221 212 Model All Hinge All Sensor Holder All Spring All Grille Shaft Ð Left All Grille Shaft Ð Right RAV-364/464CH/CHR Grille Support Ð Centre 264/364/464CH/CHR Inlet Grille Ð Large 134/164/264/364CH/CHR Inlet Grille Ð Small RAV-134/164CH/CHR Horizontal Grille RAV-264CH/CHR-PE Horizontal Grille RAV-364CH/CHR Horizontal Grille RAV-464CH/CHR Horizontal Grille All Vertical Grille All Bolt Cover All Shaft Holder All Lever 134/164/264CH/CHR Fan Ð Multi Blade 364/464CH/CHR Fan Ð Multi Blade RAV-134CH/CHR Fan Motor RAV-164/264CH/CHR Fan Motor RAV-364CH/CHR Fan Motor RAV-464CH/CHR Fan Motor 164/264/364/464CH/CHR Bearing 164/264/364/464CH/CHR Coupling RAV-164CH/CHR Shaft SS RAV-264CH/CHR Shaft SS RAV-364CH/CHR Shaft SS RAV-464CH/CHR Shaft SS 134/164/264CH/CHR Fan Case ÐÊLower 364/464CH/CHR Fan Case ÐÊLower 134/164/264CH/CHR Fan Case Ð Upper 364/464CH/CHR Fan Case Ð Upper All Connect Bar 264/464CH/CHR Connect Bar RAV-134CH/CHR Refrigeration Assembly RAV-164CH/CHR Refrigeration Assembly RAV-264CH/CHR Refrigeration Assembly RAV-364CH/CHRÊ Refrigeration Assembly 66 Ref No. 223 224 224 224 224 225 226 226 226 226 227 228 229 230 231 232 233 234 235 236 237 238 239 240 241 242 242 242 242 243 243 243 243 244 244 244 244 Part No. 43A44029 43155101 43155138 43A55001 43155080 43A70007 43172121 43172119 43172122 43172123 43179107 43180284 43180283 43A88011 43A21008 43A50005 43A50004 43102624 43102625 43117812 43A58004 43A60001 43A60010 43A69010 43A69012 43A91001 43A91002 43A91003 43A91004 43A91040 43A91041 43A91042 43A91043 43A91005 43A91006 43A91007 43A91008 236 210 Description Refrigeration Assembly MF Capacitor MF Capacitor MF Capacitor MF Capacitor Hose Assembly Drain Pan Assembly Drain Pan Assembly Drain Pan Assembly Drain Pan Assembly Plug Air Filter Ð Large Air Filter Ð Small Owners Manual Geared Motor Sensor ÐÊRoom Temp.(TA) Sensor ÐÊH/Exchanger (TC) Side Panel Right Assmb. Side Panel Left Assmb. Plate H Transformer Ð AI Terminal Block 123 Terminal Block ABC XY PC Board (AI) Infra-Red Receiver Under Panel Under Panel Under Panel Under Panel Under Panel (Remote) Under Panel (Remote) Under Panel (Remote) Under Panel (Remote) Upper Panel Asm Upper Panel Asm Upper Panel Asm Upper Panel Asm 201 202 Model RAV-464CH/CHR RAV-134CH/CHR RAV-164/264CH/CHR RAV-364CH/CHR RAV-464CH/CHR All RAV-134/164CH/CHR RAV-264CH/CHR RAV-364CH/CHR RAV-464CH/CHR All 134/164/264CH/CHR 264/364/464CH/CHR All All All All All All All All All All All All RAV-134/164CH RAV-264CH RAV-364CH RAV-464CH RAV-134/164CHR RAV-264CHR RAV-364CHR RAV-464CHR RAV-134/164CH/CHR RAV-264CH/CHR RAV-364CH/CHR RAV-464CH/CHR 7. EXPLODED VIEWS AND PARTS LISTS 7.3 Indoor Unit RAV134KH/KHR-PE RAV164KH/KHR-PE RAV264KH/KHR-PE Indoor Unit RAV-134KH/KHR-PE RAV-164KH/KHR-PE RAV-264KH/KHR-PE 226 220 207 202 217 210 216 206 213 218 209 208 205 204 201 203 221 228 223 222 212 224 211 214 215 229 230 219 227 225 Ref No. 201 201 202 203 204 204 204 205 206 207 208 209 210 210 210 211 211 212 213 213 214 Part No. 43A21016 43A21017 43A69010 43A58004 43155100 43155101 43A55002 43A60001 43A60011 43A60002 43A50008 43A50009 43A44049 43A44050 43A44051 43172112 43172114 43170182 43A09005 43A09006 43A09003 Description Model Fan Ð Motor RAV-134/164KH/KHR-PE Fan Ð Motor RAV-264KH/KHR-PE PC Board Ð (AI) All Transformer Ð (AI) All Capacitor RAV-134KH/KHR-PE Capacitor RAV-164KH/KHR-PE Capacitor RAV-264KH/KHR-PE Terminal 123 All Terminal XY All Terminal ABC All Sensor Ð Room Temperature TA All Sensor Ð Heat Exchanger TC All Refrigeration ASM RAV-134KH/KHR-PE Refrigeration ASM RAV-164KH/KHR-PE Refrigeration ASM RAV-264KH/KHR-PE Drain Pan RAV-134/164KH/KHR-PE Drain Pan RAV-264KH/KHR-PE Drain Hose All H-Grille RAV-134/164KH/KHR-PE H-Grille RAV-264KH/KHR-PE V-Grille All Ref No. 215 216 217 217 218 219 220 221 222 222 223 224 225 226 226 227 228 228 229 230 67 Part No. 43A39004 43022189 43120135 43120136 43A09004 43A80008 43A00001 43A00002 43A00003 43A01005 43121533 43A19002 43107215 43122028 43122029 43119394 43A91050 43A91051 43A69012 43A88011 Description Connection Bar Bearing Cross Flow Fan Cross Flow Fan Inlet Grille Air Filter Side Cabinet Ð Left Side Cabinet Ð Right Control Panel Control Panel - Remote Geared Motor Sensor Holder, TA Sensor Holder, TC Fan Nose Fan Nose Lever D Cabi Ð Assembly D Cabi Ð Assembly Infra Red Receiver Ð (AI) OwnerÕs Manual Model All All RAV-134/164KH/KHR-PE RAV-264KH/KHR-PE All All All All KH models only KHR models only All All All RAV-134/164KH/KHR-PE RAV-264KH/KHR-PE All RAV-134/164KH/KHR-PE RAV-264KH/KHR-PE KHR models only All 7. EXPLODED VIEWS AND PARTS LISTS 7.4 Indoor Indoor Unit Unit Indoor Unit RAV-104NH-PE RAV-14NH-PE RAV-104NH-PE RAV-134NH-PE RAV-134NH-PE RAV-134NH-PE RAV-164NH-PE RAV-164NH-PE RAV-164NH-PE RAV-264NH-PE RAV-264NH-PE RAV-264NH-PE 220 217 209 214 215 216 210 206 218 212 213 219 205 208 203 204 207 201 202 Ref No. 201 201 201 202 202 203 203 204 205 206 207 207 208 209 209 209 209 210 210 210 210 211 211 212 213 214 215 216 217 218 219 220 Part No. Description Model 43A21013 43A21004 43A21020 43126127 43126129 43126128 43126130 43125143 43125142 43125131 43120172 43120174 43107215 43A44045 43A44046 43A44047 43A44048 43155101 43A55002 43155138 43155101 43A80006 43A80007 43A50004 43A50003 43A58004 43A60001 43A60010 43A69010 43A70004 43170197 43A88011 Fan Motor Fan Motor Fan Motor Fan Case Lower Fan Case Lower Fan Case Upper Fan Case Upper SS Shaft Coupling Bearing Multi Blade Fan Multi Blade Fan Sensor Holder Refrigeration Assembly Refrigeration Assembly Refrigeration Assembly Refrigeration Assembly MF Capacitor MF Capacitor MF Capacitor MF Capacitor Filter Filter Sensor Ð Heat Exchanger TC Sensor Ð Room Temp TA Transformer Ð (AI) Terminal Block 123 Terminal Block ABCXY PC Board Ð (AI) Drain Catch Assembly Drain Hose OwnerÕs Manual RAV-104/134NH-PE RAV-164NH-PE RAV-264NH-PE RAV-104/134/164NH-PE RAV-264NH-PE RAV-104/134/164NH-PE RAV-264NH-PE RAV-164NH-PE RAV-164NH-PE RAV-164NH-PE RAV-104/134/164NH-PE RAV-264NH-PE All RAV-104NH-PE RAV-134NH-PE RAV-164NH-PE RAV-264NH-PE RAV-104NH-PE RAV-134NH-PE RAV-164NH-PE RAV-264NH-PE RAV-104NH-PE RAV-134/164/264NH-PE All All All All All All All All All 68 211 7. EXPLODED VIEWS AND PARTS LISTS 7.5 Indoor Unit RAV-164SH/SHR-PE RAV-264SH/SHR-PE Indoor Unit RAV-164SH/SHR-PE RAV-264SH/SHR-PE 234 236 204 237 223 209 225 230 235 239 242 238 231 232 232 224 226 233 216 211 229 218 205 228 215 203 214 220 219 217 227 201 241 240 208 213 222 221 207 210 212 Ref No. 201 202 203 204 205 207 208 209 209 210 211 212 213 214 215 216 217 218 218 219 220 221 222 223 223 Part No. 43107214 43107215 43107216 43107223 43107222 43109321 43109322 43109324 43109320 43109329 43119373 43119393 43119394 43120172 43A21005 43125131 43125142 43125143 43125141 43126127 43126128 43A39004 43A39005 43A44052 43A44053 Description Model Hinge Sensor Holder Spring Grille Shaft Left Grille Shaft Right Inlet Grille Large Inlet Grille Small Louvre Louvre Vertical Grille Bolt Cover Shaft Holder Lever Fan, Multi Blade Fan Motor Bearing Coupling Shaft SS Shaft SS Fan Case Lower Fan Case Upper Connect Bar Connect Bar Refrigeration Assembly Refrigeration Assembly All All All All All RAV-264SH/SHR-PE All RAV-464SH/SHR-PE RAV-264SH/SHR-PE All All All All All All RAV-264SH/SHR-PE RAV-264SH/SHR-PE RAV-164SH/SHR-PE RAV-264SH/SHR-PE All All All RAV-264SH/SHR-PE RAV-164SH/SHR-PE RAV-264SH/SHR-PE Ref No. 224 224 225 226 226 227 228 229 230 231 232 233 234 235 236 237 238 239 240 241 241 241 241 242 242 69 Part No. 43155101 43155138 43A70007 43A72002 43A72003 43179107 43180283 43180284 43A88011 43A50005 43A50004 43102624 43102625 43117812 43A58004 43A60001 43A60010 43A69010 43A69012 43A91046 43A91044 43A91047 43A91045 43A91052 43A91053 202 Description Model MF Capacitor MF Capacitor Hose Assembly Drain Pan Assembly Drain Pan Assembly Plug Air Filter Small Air Filter Large OwnerÕs Manual Sensor Ð room temperature RAV-164SH/SHR-PE RAV-264SH/SHR-PE All RAV-164SH/SHR-PE RAV-264SH/SHR-PE All RAV-264SH/SHR-PE RAV-164SH/SHR-PE All All All All All All All All All All RAV-164/264SH/SHR-PE RAV-164SH-PE RAV-164SHR-PE RAV-264SH-PE RAV-264SHR-PE RAV-164SH/SHR-PE RAV-264SH/SHR-PE Sensor Ð heat exchanger (TC) Side Panel Assm Ð right Side Panel Assm Ð left Plate H Transformer Ð (AI) Terminal Block Ð 123 Terminal Block Ð ABCXY PC Board Ð (AI) Infra-red Receiver Ð (AI) Underpanel Underpanel Ð (remote) Underpanel Underpanel Ð (remote) Upper panel Upper panel 7. EXPLODED VIEWS AND PARTS LISTS 7.6 Indoor Unit RAV-104TUH-PE RAV-134TUH-PE RAV-164TUH-PE Indoor Unit RAV-104TUH-PE RAV-134TUH-PE RAV-164TUH-PE 219 217 218 220 222 201 214 221 216 203 205 204 207 206 208 209 202 210 213 211 212 214 215 Ref No. 201 202 203 204 205 206 207 208 209 210 211 212 213 213 213 214 215 216 217 218 218 219 220 221 222 Part No. 43A22001 43020288 43151217 43A70003 43020253 43071019 43070164 43A60010 43A60001 43A21014 43A50006 43A22002 43A44042 43A44043 43A44044 43039240 43A72001 43A88011 43A69008 37555721 43155100 43A69010 43A58004 43A50004 43A50008 214 Description Model Casing Assembly All Fan All Float Switch All Pump Assembly All Bearing All Drain Connection All Drain Hose All Terminal ABC XY All Terminal 123 All Fan Motor All Sensor Holder All Casing Outlet All Heat Exchanger RAV-104TUH-PE Heat Exchanger RAV-134TUH-PE Heat Exchanger RAV-164TUH-PE Canoe Clip All Drain Pan All OwnerÕs Manual All Interface PC Board All Capacitor, Metal Film RAV-104TUH-PE RAV-134/164TUH-PE Capacitor, Metal Film All PC Board - (AI) All Transformer - (AI) All Sensor - Heat Exchanger (TC) All Sensor - Room Temperature (TA) 70 7. EXPLODED VIEWS AND PARTS LISTS 7.7 Indoor Unit RAV-164UH-PE Indoor Unit RAV-264UH-PE RAV-164UH-PE RAV-264UH-PE 201 223 206 205 203 202 204 215 217 219 220 207 222 216 212 211 208 213 218 209 221 214 210 Ref No. 201 202 202 203 204 205 206 207 208 209 210 211 212 213 214 215 216 217 218 218 219 220 221 222 223 Part No. 43A70005 43A44033 43A44034 43A70006 43A51002 43A21018 43A11004 43A20001 43A72006 43A22003 43A19004 43A58004 43A69010 43A50007 43A50005 43A60001 43A60002 43A60011 43155100 43A55002 43097166 43A97002 43A72008 43107215 43A88011 Description Model Drain Hose Assembly Refrigeration Assembly Refrigeration Assembly Drain Pump Float Switch Fan Motor Rubber Insulation Centrifugal Fan Drain Pan Assembly Bellmouth Fan Guard Transformer (AI) PC Board (AI) Sensor - Heat Exchanger (TC) Sensor - Room Temp. (TA) Terminal 123 Terminal ABC Terminal X,Y MF Capacitor MF Capacitor Washer Fan Washer Plug Sensor Holder OwnerÕs Manual All RAV-164UH-PE RAV-264UH-PE All All All All All All All All All All All All All All All RAV-164UH-PE RAV-264UH-PE All All All All All 71 7. EXPLODED VIEWS AND PARTS LISTS Unit Indoor Unit 7.8Indoor RAV-364UH-PE RAV-364UH-PE RAV464UH-PE RAV-464UH-PE 205 206 201 202 223 207 203 219 204 215 220 217 216 212 221 211 208 209 213 218 214 222 210 Ref No. 201 202 202 203 204 205 206 207 208 209 210 211 212 213 214 215 216 217 218 218 219 220 221 222 223 Part No. 43A70005 43A44035 43A44036 43A70006 43A51002 43A21019 43A11005 43A20002 43A72007 43A22004 43A19005 43A58004 43A69010 43A50007 43A50005 43A60001 43A60002 43A60011 43155138 43155120 43097166 43A97002 43A72008 43107215 43A88011 Description Model Drain Hose Assembly Refrigeration Assembly Refrigeration Assembly Drain Pump Float Switch Fan Motor Rubber Insulation Centrifugal Fan Drain Pan Assembly Bellmouth Fan Guard Transformer (AI) PC Board (AI) Sensor - Heat Exchanger Sensor - Room Temp. Terminal 123 Terminal ABC Terminal X,Y MF Capacitor MF Capacitor Washer Fan Washer Plug Sensor Holder OwnerÕs Manual RAV-364/464UH-PE RAV-364UH-PE RAV-464UH-PE RAV-364/464UH-PE RAV-364/464UH-PE RAV-364/464UH-PE RAV-364/464UH-PE RAV-364/464UH-PE RAV-364/464UH-PE RAV-364/464UH-PE RAV-364/464UH-PE RAV-364/464UH-PE RAV-364/464UH-PE RAV-364/464UH-PE RAV-364/464UH-PE RAV-364/464UH-PE RAV-364/464UH-PE RAV-364/464UH-PE RAV-364UH-PE RAV-464UH-PE RAV-364/464UH-PE RAV-364/464UH-PE RAV-364/464UH-PE RAV-364/464UH-PE RAV-364/464UH-PE 72 7. EXPLODED VIEWS AND PARTS LISTS 7.9 Outdoor Unit Outdoor Unit RAV-134AH-PE RAV-134AH-PE RAV-164AH-PE RAV-164AH-PE RAV-264AH-PE RAV-264AH-PE RAV-264AH8-PE RAV-264AH8-PE 41 7 1 21 22 13 17 43 30 12 45 36 9 11 10 3 2 18 32 33 38 44 15 23 35 39 19 29 37 34 5 25 6 4 28 24 8 27 20 26 16 31 14 40 Ref No. 1 2 2 3 3 4 5 6 7 8 9 10 10 10 11 12 12 13 14 15 16 17 18 19 19 20 21 21 22 23 23 Part No. 43120156 43A21003 43A21002 43A43016 43A43017 43049132 43149212 43149198 43A69011 43A49001 43060479 43A60003 43A60004 43A60005 43A60001 43152334 43152345 43A19001 43119368 43A46004 43162027 43107215 43A63001 43148105 43148114 43A45004 43155115 43055379 43155080 43A41506 43A41507 Description Model Propeller Fan All Fan Motor RAV-134/164AH-PE Fan Motor RAV-264AH/AH8-PE Condenser RAV-134/164AH-PE Condenser RAV-264/AH/AH8-PE Base Spring, B All Base Spring, A All Spring Buffer All PC Board All High Pressure Switch All Terminal Block, 4P All Terminal Block, 2P RAV-134/164AH-PE Terminal Block, 2P RAV-264AH-PE Terminal Block, 4P RAV-264AH8-PE Terminal Block, 4P All Magnetic Contactor RAV-134/164/264AH-PE Magnetic Contactor RAV-264AH8-PE Fan Guard All Hanger All Solenoid Coil All Cover, Electrical Parts All Sensor Holder All Cord Clamp All RAV-134/164AH-PE Accumulator RAV-264AH/AH8-PE Accumulator All Dryer MF Capacitor Ð Compressor RAV-134/164AH-PE RAV-264AH-PE MF Capacitor Ð Compressor All MF Capacitor Ð Fan RAV-134AH-PE Comp Ð PG330X3F-4LS RAV-164AH-PE Comp Ð PG350X3F-4LS 73 Ref No. 23 23 24 24 25 25 26 27 27 28 29 30 31 32 33 34 35 36 37 38 39 40 40 41 42 42 43 43 44 44 45 42 Part No. 43A41508 43A41509 43A46013 43146415 43146406 43146417 43A46015 43A46014 43A46017 43A46016 43146283 43A58003 43046151 43A50001 43A19001 43193063 43157167 43150122 43050277 43A60006 43146418 43A47037 43A47036 43A91016 43A91019 43A91022 43A91017 43A91018 43A91023 43A91024 43154148 Description Model Comp Ð PG460X3F-4MS Comp Ð YG460X3F-MS Packed Valve (6.35mm) Packed Valve (9.5mm) Packed Valve (12.7mm) Packed Valve (15.9mm) Check joint Expansion Valve Expansion Valve Coil, 2-Way Valve Check Valve Transformer Power 2-Way Valve Sensor Ð Heat Exchanger (TL) Sensor Ð Heat Exchanger (TC) Spring Heater, Crankcase Thermostat, Bi-metal Thermostat, Bi-metal (comp) Fuse T5A 4-Way Valve Capi Form Capi Form ASM Roof Plate ASM Side Cabinet ASM Side Cabinet ASM Air-Out Cabinet ASM Air-Out Cabinet Fin-Guard Fin-Guard Reverse Phase Protector RAV-264AH-PE RAV-264AH8-PE RAV-134/164AH-PE RAV-264AH/AH8-PE RAV-134/164AH-PE RAV-264AH/AH8-PE All RAV-134/164AH-PE RAV-264AH/AH8-PE All All All All All All All All All RAV-264AH8-PE All All RAV-134/164AH-PE RAV-264AH/AH8-PE All RAV-134/164AH-PE RAV-264AH/AH8-PE RAV-134/164AH-PE RAV-264AH/AH8-PE RAV-134/164AH-PE RAV-264AH/AH8-PE RAV-264AH8-PE 7. EXPLODED VIEWS AND PARTS LISTS Unit 7.10 Outdoor Outdoor Unit RAV-364AH8-PE RAV-364AH8-PE RAV-464AH8-PE RAV-464AH8-PE 37 4 41 6 3 33 27 1 24 38 32 20 19 21 22 36 25 26 34 14 8 39 15 2 28 29 18 7 9 30 40 5 12 23 11 31 13 16 10 35 17 Ref No. 1 2 3 4 5 5 6 6 7 8 9 9 10 11 11 12 13 14 15 15 16 17 17 18 18 19 Part No. 43A21002 43A21003 43120156 43A19001 43A43012 43A43014 43A43013 43A43015 43119368 43162027 43A41503 43A41502 43A42001 43A46008 43A46009 43146415 43146416 43147321 43146499 43146498 43146283 43A45001 43A45002 43148114 43148105 43155080 Description Fan Motor AC230V, 50Hz 63W Fan Motor AC230V, 50Hz 39W Propeller Fan Fan Guard Condenser Lower Condenser Lower Condenser Upper Condenser Upper Hanger, Plastic Cover, Electrical Parts Compressor, ZR61KCE-TFD-230 Compressor,ZR49KCE-TFD-230 Compressor Boot Expansion Valve, BGX-2330 3.65DPS Expansion Valve, BGX-2330 3.5DPS Packed Valve, (9.5mm) Packed Valve, (19mm) Check Joint 4-Way-Valve, CHV-0401 4-Way-Valve, CHV-0301 Check Valve, YCV5-3S-TF Dryer, XH10 Dryer, XH10 Accumulator, 2.5Ltr Accumulator, 1.6Ltr Capacitor, Plastic Film, 4.0mF, 400V Model All All All All RAV-464AH8-PE RAV-364AH8-PE RAV-464AH8-PE RAV-364AH8-PE All All RAV-464AH8-PE RAV-364AH8-PE All RAV-464AH8-PE RAV-364AH8-PE All All All RAV-464AH8-PE RAV-364AH8-PE All RAV-464AH8-PE RAV-364AH8-PE RAV-464AH8-PE RAV-364AH8-PE All 74 Ref No. 20 21 22 23 24 25 26 27 28 29 30 31 31 32 33 34 35 36 37 38 38 39 40 40 41 Part No. 43060479 43A60005 43A60001 43107215 43A53004 43150196 43A50001 43A69011 43A46004 43A49001 43157167 43A47032 43A47033 43A58003 43154148 43150261 43063219 43A60006 43A91027 43A91037 43A91029 43A91028 43A91036 43A91031 43A91030 Description Terminal Block, 4P Terminal, 4P Terminal, 4P Sensor Holder Magnetic Contactor, FC-2S Sensor, Heat Exchanger TE Sensor (Cond Out), TL PC Board, AH-803 Solenoid Coil, CHV-AC240V High Pressure Switch, ACB-2TB04W Crankcase Heater, AC240V, 28W Capillary Assembly Capillary Assembly Power Transformer, FT67 Reverse Phase Protector, STR-4AD Sensor (Delivery Pipe), TD Sensor Holder, TD Fuse T5A ASM Roof Plate ASM Side Cabi ASM Side Cabi Air Out Cabi Fin Guard Ð Back Fin Guard Ð Back Fin Guard Ð Side Model All All All All All All All All All All All RAV-464AH8-PE RAV-364AH8-PE All All All All All All RAV-464AH8-PE RAV-364AH8-PE All RAV-464AH8-PE RAV-364AH8-PE All 7. EXPLODED VIEWS AND PARTS LISTS 7.11 Ceiling Panel RBC-U133PG(W)-PE Ceiling Panel RBC-U133PG(W)-PE 10 8 7 5 9 10 2 6 7 1 3 4 Ref No. 1 2 3 4 5 Part No. 43080392 43007108 43009504 43007107 43007109 Ref No. 6 7 8 9 10 Description Filter Plate connect (long) ASM-Grille-Out Bushing Plate connect (short) 75 Part No. 43009503 43007124 43009499 43A26001 43007125 Description Grille-L-R Support plate ASM-Grille-Out ASM-Motor Support plate 7. EXPLODED VIEWS AND PARTS LISTS 7.12 Ceiling Panel RBC-U264PG(W)-E RBC-U264PGR(W)-E Ceiling Panel RBC-U264PG(W)-E RBC-U264PGR(W)-E 11 12 15 16 13 4 7 12 1 6 2 17 9 Ref No. 1 1 2 4 5 6 7 9 11 12 13 14 15 16 17 Part No. 43400658 43400001 43407072 43407085 43407091 43107249 43409110 43A09009 43411007 43411008 43411009 43121671 43460532 43A69012 41480545 Description Panel Panel (Remote) Grille Catch Joint Kit Cam Motor Kit Assembly Louver-(Small) Grille Ð Air Inlet Cushion Air Outlet B Cushion Air Outlet C Cushion Air Outlet D Geared Motor Cord, Remote Controller Infra-Red Receiver - (AI) Air Filter 76 14 Model RBC-U264PG(W)-E RBC-U264PGR(W)-E All All All All All All All All All All RBC-U264PGR(W)-E RBC-U264PGR(W)-E All 5 7. EXPLODED VIEWS AND PARTS LISTS 7.13 Ceiling Panel RBC-U464PG(W)-E RBC-U464PGR(W)-E Ceiling Panel RBC-U464PG(W)-E RBC-U464PGR(W)-E 11 10 7 13 4 15 8 16 10 1 6 2 9 5 17 14 3 Ref No. 1 1 2 3 4 5 6 7 8 9 10 11 13 14 15 16 17 Part No. 43400662 43400003 43407072 43407076 43407085 43402091 43107249 43409110 43409114 43A09010 43411006 43411007 43411009 43121671 43460532 43A69012 41480546 Description Panel Panel (Remote) Grille Catch Grille, Louvre M Joint Kit Cam Motor Kit Assembly Louver Ð (Small) Louver Ð (Large) Grille Air Inlet Cushion Air Outlet A Cushion Air Outlet B Cushion Air Outlet D Geared Motor Cord, Remote Controller Infra Red Receiver Air Filter 77 Model RBC-U464PG(W)-E RBC-U464PGR(W)-E All All All All All All All All All All All All RBC-U464PGR(W)-E RBC-U464PGR(W)-E All Notes 78 Notes 79 TOSHIBA AIR CONDITIONING PORSHAM CLOSE, BELLIVER INDUSTRIAL ESTATE, PLYMOUTH PL6 7DB UK A division of Toshiba Carrier UK Ltd