1
Download Sony TAM-100 User's Manual
Transcript
TAM-100 SERVICE MANUAL Canadian Model SPECIFICATIONS TELEPHONE ANSWERING MACHINE MICROFILM TABLE OF CONTENTS 1. GENERAL 2. 2-1. 2-2. 2-3. 2-4. DIAGRAMS ................................................................. Block Diagram ................................................................ Printed Wiring Board –KEY Section– .......................... Printed Wiring Board –MAIN Section– ........................ Schematic Diagram ......................................................... 3. EXPLODED VIEW ................................................... 13 4. ELECTRICAL PARTS LIST ............................... 15 SECTION 1 GENERAL –2– 5 5 7 9 11 This section is extracted from instruction manual. –3– –4– TAM-100 SECTION 2 DIAGRAMS 2-1. BLOCK DIAGRAM U1 DSP T70 + – ECM MIC W B U80 SPEAKER AMP 76 TI VOICE DET Q70 77 TI + 78 VREF M2C MUTE PD1 59 1 SPOI + 80 4 BIAS SP901 SPEAKER 5 JP100 MODULER JACK TEL MODULER JACK LINE 1 2 1 2 58 PD2 R G + 3 60 PD0 D100-103 LINE SW Q110, 111 R G JP101 SPEECH NETWORK Q120, 121 54 PB2 BRANCH DET Q112, 113 28 A8/PJ0 +B 27 A9/PJ1 ANSWER ON/OFF MAIL BOX1-3 LED INDICATOR U2 FLASH MEMORY 57 PD3 RINGER DET ZD100, 101 D104 LED1-4 A14/P12 22 A12/P10 24 • PB1 55 • PB0 56 PA0 PA2 PA3 PA4 48 46 45 44 PB7 PB4 A3/PM3 A0/PM0 49 52 • 33 36 4 5 6 7 CS SK D1 D0 PH100 RINGER DET + JP90 1 DC JACK – DC IN 12V +5V REG 2 U90 SW1 AUDIBLE INDICATOR +5V OFF 29 A7/PK3 ON 30 A6/PK2 ANN ONLY PUSH BUTTON KEY TIME MEMO ERASE ANSWER ON/OFF SET/REC MAIL BOX 3 GREETING MAIL BOX 2 VOL + 53 PB3 REPEAT SW2 2 32 A4/PK0 RINGER SELECT 5 31 A5/PK1 TS WE 3 CAST PC3-0 10 RAS • OE 61 IORQ MREQ 64 PEI • PEO 69 RD • WR 70 –5– MAIL BOX 1 LED5 88 7 SEGMENT LED SKIP VOL – • IC Block Diagrams SPO2- DAO SPI1 SPO1+ SPO1- VREF TI+ TI- TO ADI 92 91 90 89 SPO2+ MODE0-3 RST STBY 95 94 93 AVDD1, 2 AVSS1, 2 100 MODE0-3 DVDD1-4 DVSS1-4 TC88512AF-043 D7-D0 U1 87 86 85 84 83 82 81 80 79 78 77 76 75 74 1 1 1 VRFF GENERATOR D-A CONVERTER A-D CONVERTER DPS • VOICE COMPRESSION/DECOMPRESSION • DTMF DETECTION • FULL DUPLEX HANDS FREE AND SO ON CLOCK COUNTER WE/PF0 CAS1/PF2 1 . 2 3 4 8 BIT CPU DSP INTERFACE MEMORY INTERFACE 73 72 71 70 69 68 67 66 65 64 . 63 62 61 5 AVDD1, 2 AVSS1, 2 WAIT WR/PH0 RD/PH1 NM1 INT DVDD1-4 DVSS1-4 PE (1:0) MREQ/PH2 IORQ/PH3 PC (3:0) HOST SERIAL INTERFACE CLOCK GENERATOR + PLL ADDRESS DECODER 28 29 VCC NC 4M BIT MEMORY CELL ARRAY CHARGE PUMP/ CONTROL GATE DRIVE 32 33 36 NJM2113M-TE2 CHIP–DIS 1 V REF 2 BIAS 50k DATA LATCH 37, 38 39 40 41 42 DVSS1-4 RIN ROUT DVDD1-4 A15-12/PI(3:0) 24 25 U80 27 – 15 8 V02 125k #B 7 GND 50k 4k INTERFACE/ CONTROL LOGIC +VIN 3 6 V+ 6 7 8 – 14 DI DO 4k 1 2 3 4 5 VSS NC NC CS SK DECODER TC58A04F 28 PA (3:0) 45 44 . PA (7:4) 43 MEMORY SERIAL INTERFACE 22 U2 PB (7:0) 49 48 I/O CONTROL CPU RAM CPU PROGRAM ROM PA (7:4) 14 15 16 17 18 19 20 21 PD (3:0) 57 56 A3-0/PM(3:0) DVSS1-4 XIN XOUT DVDD1-4 PVSS PLLI PLLO PVDD 60 A7-4/PK(3:0) 8 9 10 11 12 13 A11-8/PJ(3:0) RAS/PF3 OE/PF1 MCE A 16 A15-12/PI(3:0) NC –VIN #A 4 –6– 5 V01 TAM-100 THIS NOTE IS COMMON FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS. (In addition to this, the necessary note is printed in each block.) • Waveform 2-2. PRINTED WIRING BOARD — KEY SECTION — 1 KEY BOARD 5.6Vp-p For schematic diagrams. Note: • All capacitors are in µF unless otherwise noted. pF: µµF 50 WV or less are not indicated except for electrolytics and tantalums. • All resistors are in Ω and 1/4 W or less unless otherwise specified. ¢ • : internal component. • C : panel designation. • U : B+ Line. • Voltage and waveforms are dc with respect to ground under no-signal conditions. no mark : Add to DC 12V and fed with regulated dc power supply from external power voltage jack. : Impossible to measure ∗ • Indication of transistor 4MHz U1 !§ (XOUT) MEMO 16 9 ANSWER ON/OFF LED1 A K ERASE 1 8 LED5 C Q These are omitted B E • Voltages are taken with a VOM (Input impedance 10 MΩ). Voltage variations may be noted due to normal production tolerances. • Waveforms are taken with a oscilloscope. Voltage variations may be noted due to normal production tolerances. • Circled numbers refer to waveforms. • Signal path. F : AUDIO • Abbreviation CND : Canadian model TIME VOL+ VOL- GREETING SET/REC MAIL BOX3 LED4 A K QUICK/SKIP MAIL BOX2 For printed wiring boards. Note: • : carbon pattern • X : parts extracted from the component side. ¢ • : internal component. • b : Pattern from the side which enables seeing. LED3 A K SLOW/ REPEAT 1 27 W1 LED2 A K MAIL BOX1 PLAY/STOP 1-673-413- 09 A –7– –8– MAIN BOARD (Page 8) 11 TAM-100 2-3. PRINTED WIRING BOARD — MAIN SECTION — R73 E Q71 C70 R72 Q70 ZD100 R100 C71 R71 R124 R74 R22 C10 R23 R24 SP901 SPEAKER R55 TP5 1 5 R28 TP4 R21 R19 W1 R32 (Page 8) 20 R35 C9 R13 R12 MAIN BOARD R10 R4 4 1 TP82 A 15 R27 TP7 U80 2 10 R16R15 C81 C83 R26 R85 TP2 TP6 TP1 R30 C80 C19 R20 A TP3 X1 C6 TP8 C20 R83 C60 C8 WHT C13 R1 R33 R11 R18 25 R38 R80 5 C82 R82 C86 R84 D91 1 C12 R25 F C11 R3 C7 C18 C91 C85 C5 R51 U90 C84 28 R81 C120 C51 R39 C101 C92 U2 15 TP73 TP112 R101 TP93 TP92 L2 C93 TP71 PH100 L3 Q112 E B R36 R34 R128 JP101 TP91 B TP113 L1 1 C88 C50 Q121 Z101 TP90 14 E JP90 DC JACK DC IN 12V 0 50 31 C112 C2 R54 R50 R116 JP90 51 R88 C14 C CD R17 C15 C16 Q113 Z102 MODULER JACK JP101 R131 C17 RED TP102 U3 C1 TP110 C113 R115 LINE C59 R56 GRN R118 30 R114 R117 R2 R53 R125 C103 3 Q120 E R5 R52 R120 E C111 R126 C126 R130 C125 R129 R29 U1 C106 C55 C53 C54 C130 Q110 C105 4 8 C123 80 GRN C56 TP50 TP111 TP83 R9 1 D100 TP100 D R37 BLK TP72 C57 D101 D103 D T70 ECM MIC C74 TP120 250V. 500mA RED R112 TEL C C104 ZD104 2 1 E C102 TP84 81 100 C110 R122 C121 C58 R8 JP100 MODULER JACK Q111 Z100 R111 R121 R113 R119 TP101 F100 R110 R6 C100 D102 E R77 TP80 C90 B R7 YEL R123 JP100 ECM ZD101 C73 T70 C72 R70 ECM F R76 TP70 A (SIDE B) MAIN BOARD ZD70 (SIDE A) R75 MAIN BOARD BRN 09 1 2 3 4 5 6 7 11 SW1 1-673-412- 09 2 1 3 SW2 RINGER SELECT TS˜5˜2 A-3 D-5 U1 U2 D-3 E-3 5 SW1 AUDIBLE INDICATOR ANN ONLY˜ON˜OFF • Semiconductor Location Ref. No. Location • Semiconductor Location Ref. No. Location Q71 Q112 4 –9– D91 D92 D100 D101 D102 D103 B-2 B-2 E-3 D-2 E-3 D-2 Q70 Q110 Q111 Q113 Q120 Q121 F-5 D-3 E-3 D-3 D-4 C-4 U3 U80 U90 D-7 B-4 B-3 ZD70 ZD100 ZD101 ZD104 F-6 F-4 E-4 E-4 – 10 – 6 7 27 SW2 1-673-412- 11 TAM-100 2-4. SCHEMATIC DIAGRAM • Refer to page 6 for IC Block Diagrams. • Refer to page 7 for Waveforms and Note. 10V R75 470k R74 2.2k 0.1 Q71 2SC2412KR MIC AMP 10V R76 220 SP901 C84 220 10V 3 RESET U3 XC61AN4602PR 5.0 4.9 L1 10uH C93 0.1 L2 10uH L3 10uH 1W 25V 7 SEGMENT LED 4MHz 26.7 26.7 OFF ˜ ON ˜ ANN ONLY – 11 – 2 ˜ 5 ˜ TS – 12 – SECTION 3 EXPLODED VIEW NOTE: • -XX, -X mean standardized parts, so they may have some difference from the original one. • Items marked “*” are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. • Color Indication of Appearance Parts Example: KNOB, BALANCE (WHITE) . . . . (RED) Â Â Parts color Cabinets color KEY SECTION 4 ELECTRICAL PARTS LIST MAIN Note: • The mechanical parts with no reference number in the exploded views are not supplied. • Hardware (# mark) list and accessories and packing materials are given in the last of this parts list. • Abbreviation CND : Canadian model When indicating parts by reference number, please include the board name. • Due to standardization, replacements in the parts list may be different from the parts specified in the diagrams or the components used on the set. • -XX, -X mean standardized parts, so they may have some difference from the original one. • Items marked “*” are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. • RESISTORS All resistors are in ohms METAL: Metal-film resistor METAL OXIDE: Metal Oxide-film resistor F : nonflammable • SEMICONDUCTORS In each case, u: µ , for example: uA...: µ A..., uPA...: µ PA..., uPB...: µ PB..., uPC...: µ PC..., uPD...: µ PD... • CAPACITORS uF : µ F • COILS uH : µ H • Abbreviation CND : Canadian model 8 Ref. No. Part No. * 1-673-413-11 KEY BOARD ********* 6 7 Description Remark Part No. Description C72 C74 C80 C81 C82 1-163-038-00 1-104-657-11 1-163-038-00 1-163-021-11 1-163-009-11 CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.1uF 47uF 0.1uF 0.01uF 0.001u C83 C84 C85 C86 C88 1-164-346-11 1-126-934-11 1-126-935-11 1-163-038-00 1-163-015-11 ELECT ELECT ELECT CERAMIC CHIP CERAMIC CHIP 1uF 220uF 470uF 0.1uF 0.0033uF C90 C91 C92 C93 C100 1-163-038-00 1-163-038-00 1-126-925-11 1-163-038-00 1-136-193-11 CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP FILM 0.1uF 0.1uF 470uF 0.1uF 0.47uF 25V 16V 50V 50V 25V C101 C106 C110 C111 C112 1-104-657-11 1-163-017-00 1-163-009-11 1-163-033-00 1-126-961-11 ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT 47uF 0.0047uF 0.001uF 0.022uF 2.2uF 20% 5% 10% ELECT ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 33uF 100uF 0.0033uF 0.1uF 0.1uF 20% 20% 10% 10% 50V 25V 50V 25V 25V 0.01uF 0.001uF 10% 10% 50V 50V < DIODE > LED1 LED2 LED3 LED4 LED5 9 SP901 8-719-072-22 8-719-072-22 8-719-072-22 8-719-072-22 8-719-074-88 DIODE DIODE DIODE DIODE DIODE SML-310LTT86-MN (ANSWER ON/OFF) SML-310LTT86-MN (MAIL BOX 1) SML-310LTT86-MN (MAIL BOX 2) SML-310LTT86-MN (MAIL BOX 3) SL-1255-305 A-3672-702-A MAIN BOARD, COMPLETE ******************** * #2 JP100 < CAPACITOR > JP90 #2 PJ101 4 #1 10 T70 2 #2 #3 1 #3 1 Ref. No. Part No. Description 1 2 * 3 * 4 5 3-034-197-01 3-034-193-01 A-3672-702-A 1-673-413-11 1-771-695-11 FOOT, RUBBER CABINET (LOWER) MAIN BOARD, COMPLETE KEY BOARD SWITCH, RUBBER KEY 6 7 8 3-034-194-01 BUTTON 3-034-192-01 CABINET (UPPER) 3-034-196-01 WINDOW (LED) Remark Ref. No. Part No. Description 9 10 3-037-472-01 SCREW (3X5), SPECIAL 3-625-138-01 CAP, MICROPHONE JP90 JP100 JP101 SP901 T70 1-766-366-11 1-793-136-11 1-793-136-11 1-504-748-21 1-542-368-11 – 13 – Remark 20% 10% 10% 20% 20% 20% 10% 25V 10V 25V 50V 50V 50V 16V 16V 25V 50V ************************************************************** 5 3 Ref. No. Remark JACK, DC JACK, MODULAR (2C) 6P (TEL) JACK, MODULAR (2C) 6P (LINE) SPEAKER (6.6CM) MICROPHONE, ELECTRET CONDENSER C1 C2 C5 C6 C7 1-163-038-00 1-163-021-11 1-163-237-11 1-163-237-11 1-163-038-00 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.1uF 0.01uF 27PF 27PF 0.1uF C8 C9 C10 C11 C12 1-163-038-00 1-164-326-11 1-163-009-11 1-163-009-11 1-163-009-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.1uF 0.47uF 0.001uF 0.001uF 0.001uF 20% 10% 10% 10% 25V 50V 50V 50V 50V C113 C120 C121 C123 C125 1-126-966-11 1-104-665-11 1-163-015-11 1-164-004-11 1-163-038-00 C13 C14 C15 C16 C17 1-163-009-11 1-163-009-11 1-163-009-11 1-163-009-11 1-163-009-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.001uF 0.001uF 0.001uF 0.001uF 0.001uF 10% 10% 10% 10% 10% 50V 50V 50V 50V 50V C126 C130 1-163-021-11 CERAMIC CHIP 1-163-009-11 CERAMIC CHIP C18 C19 C20 C50 C51 1-163-038-00 1-163-038-00 1-163-038-00 1-163-038-00 1-164-004-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 10% 25V 25V 25V 25V 25V C53 C54 C55 C56 C57 1-126-964-11 1-163-243-11 1-163-038-00 1-104-657-11 1-163-011-11 ELECT CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP 10uF 47PF 0.1uF 47uF 0.0015uF C58 C59 C60 C70 C71 1-163-038-00 1-163-038-00 1-163-037-11 1-163-021-11 1-163-038-00 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.1uF 0.1uF 0.022uF 0.01uF 0.1uF 5% 5% 20% 5% 20% 10% 50V 50V 25V 10V 50V < DIODE > D91 D100 D101 D102 D103 8-719-991-33 8-719-970-02 8-719-970-02 8-719-970-02 8-719-970-02 DIODE DIODE DIODE DIODE DIODE 1SS133T-77 1SR139-400 1SR139-400 1SR139-400 1SR139-400 D104 8-719-991-33 DIODE 1SS133T-77 < FUSE > F100 1-533-713-11 FUSE (250V/500mA) < INDUCTOR > 10% 25V 16V 25V 25V 25V L1 L2 L3 – 14 – 1-412-058-21 INDUCTOR, CHIP 10uH 1-412-058-21 INDUCTOR, CHIP 10uH 1-412-058-21 INDUCTOR, CHIP 10uH 20% 5% 20% 25V 25V 10V 25V 250V 10V 50V 50V 50V 50V MAIN Ref. No. Part No. Description Remark < PHOTO INTERUPTER > PH100 Ref. No. Part No. Description Remark R56 R70 1-216-077-00 METAL CHIP 1-216-053-00 METAL CHIP 15K 1.5K 5% 5% 1/10W 1/10W R71 R72 R73 R74 R75 1-216-051-00 1-216-113-00 1-216-057-00 1-216-057-00 1-216-113-00 RES,CHIP METAL CHIP METAL CHIP RES,CHIP RES,CHIP 1.2K 470K 2.2K 2.2K 470K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R76 R77 R80 R81 R82 1-216-033-00 1-216-025-00 1-216-073-00 1-216-109-11 1-216-085-00 RES,CHIP RES,CHIP RES,CHIP METAL CHIP METAL CHIP 220 100 10K 330K 33K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R83 R84 R85 R88 R100 1-216-067-00 1-249-393-11 1-216-097-00 1-216-065-00 1-215-877-11 METAL CHIP CARBON RES,CHIP RES,CHIP METAL OXIDE 5.6K 10 100K 4.7K 22K 5% 5% 5% 5% 5% 1/10W 1/4W 1/10W 1/10W 1W F R101 R110 R111 R112 R113 1-216-069-11 1-216-089-00 1-216-051-00 1-216-113-00 1-216-073-00 METAL CHIP RES,CHIP METAL CHIP METAL CHIP METAL CHIP 6.8K 47K 1.2K 470K 10K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R114 R115 R116 R117 R118 1-216-073-00 1-216-105-00 1-216-089-00 1-216-113-00 1-216-089-00 METAL CHIP RES,CHIP RES,CHIP METAL CHIP RES,CHIP 10K 220K 47K 470K 47K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R119 R120 R121 R122 R123 1-216-057-00 1-216-063-00 1-216-075-00 1-216-061-00 1-260-082-11 METAL CHIP RES,CHIP METAL CHIP METAL CHIP CARBON 2.2K 3.9K 12K 3.3K 39 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/2W R124 R125 R126 R128 R129 1-260-082-11 1-216-051-00 1-216-075-00 1-216-113-00 1-216-073-00 CARBON METAL CHIP METAL CHIP METAL CHIP METAL CHIP 39 1.2K 12K 470K 10K 5% 5% 5% 5% 5% 1/2W 1/10W 1/10W 1/10W 1/10W R130 R131 1-216-109-00 METAL CHIP 1-216-057-00 METAL CHIP 330K 2.2K 5% 5% 1/10W 1/10W 8-749-015-01 PHOTO COUPLER 5817P6 < TRANSISTOR > Q70 Q71 Q110 Q111 Q112 8-729-901-81 8-729-901-81 8-729-045-65 8-729-045-48 8-729-026-49 TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR 2SC2412K 2SC2412K-T-146-R 2SA1776TV2Q 2SC3415STPP 2SA1037AK-T146-R Q113 Q120 Q121 8-729-901-81 TRANSISTOR 2SC2412K 8-729-032-94 TRANSISTOR 2SD1859TV2Q 8-729-901-81 TRANSISTOR 2SC2412K < RESISTOR > R1 R2 R3 R4 R5 1-216-063-00 1-216-089-00 1-216-121-00 1-216-051-00 1-216-051-00 RES,CHIP RES,CHIP RES,CHIP METAL CHIP METAL CHIP 3.9K 47K 1M 1.2K 1.2K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R6 R7 R8 R9 R10 1-216-051-00 1-216-051-00 1-216-051-00 1-216-051-00 1-216-051-00 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 1.2K 1.2K 1.2K 1.2K 1.2K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R11 R12 R13 R15 R16 1-216-051-00 1-216-170-00 1-216-045-00 1-216-051-00 1-216-051-00 METAL CHIP RES,CHIP METAL CHIP METAL CHIP METAL CHIP 1.2K 68 680 1.2K 1.2K 5% 5% 5% 5% 5% 1/10W 1/8W 1/10W 1/10W 1/10W R17 R18 R19 R20 R21 1-216-051-00 1-216-073-00 1-216-073-00 1-216-073-00 1-216-073-00 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 1.2K 10K 10K 10K 10K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R22 R23 R24 R25 R26 1-216-097-00 1-216-097-00 1-216-097-00 1-216-097-00 1-216-097-00 RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP 100K 100K 100K 100K 100K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R27 R28 R29 R30 R32 1-216-097-00 1-216-097-00 1-216-097-00 1-216-093-11 1-216-051-00 RES,CHIP RES,CHIP RES,CHIP RES,CHIP METAL CHIP 100K 100K 100K 68K 1.2K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R33 R34 R35 R36 R37 1-216-051-00 1-216-051-00 1-216-051-00 1-216-051-00 1-216-051-00 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 1.2K 1.2K 1.2K 1.2K 1.2K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R38 R39 R50 R51 R52 1-216-051-00 1-216-051-00 1-216-077-00 1-216-105-00 1-216-308-00 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 1.2K 1.2K 15K 220K 4.7 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W R53 R54 R55 1-216-085-00 METAL CHIP 1-216-073-00 METAL CHIP 1-216-077-00 METAL CHIP 33K 10K 15K 5% 5% 5% 1/10W 1/10W 1/10W < SWITCH > SW1 SW2 1-692-207-21 SWITCH, SLIDE (AUDIBLE INDICATOR) 1-692-207-21 SWITCH, SLIDE (RINGER SELECT) < IC > U1 U2 U3 U80 U90 8-759-589-79 8-759-489-92 8-759-596-96 8-759-291-01 8-759-450-47 IC IC IC IC IC TC88512AF-043 TC58A040F XC61AN4602PR NJM2113M-TE2 BA05T < VIBRATOR > X1 1-579-734-11 VIBRATOR, CRYSTAL (4.000MHz) < GAP > Z100 – 15 – 1-533-751-11 GAP, DISCHARGE TAM-100 MAIN Ref. No. Part No. Description Remark < DIODE > ZD70 ZD100 ZD101 8-719-923-56 DIODE MTZJ-T-77-8.2B 8-719-923-38 DIODE MTZJ-T-77-5.6B 8-719-923-38 DIODE MTZJ-T-77-5.6B ************************************************************** MISCELLANEOUS ************* 5 JP90 JP100 JP101 T70 1-771-695-11 1-766-366-11 1-793-136-11 1-793-136-11 1-542-368-11 SWITCH, RUBBER KEY JACK, DC (DC IN 12V) JACK, MODULAR (2C) 6P (TEL) JACK, MODULAR (2C) 6P (LINE) MICROPHONE, ELECTRET CONDENSER SP901 1-504-748-21 SPEAKER (6.6CM) ************************************************************** ************* HARDWARE LIST ************* #1 #2 #3 7-685-132-19 SCREW +PTPWH 2.6X5 (TYPE2) 7-685-133-19 SCREW +BTP 2.6X6 TYPE2 N-S 7-685-547-11 SCREW +BTP 3X10 TYPE2 N-S ************************************************************** PARTSFORINS TALLATION AND CONNECTIONS ************************************** 51 52 53 54 1-418-458-11 1-696-454-11 3-866-411-21 3-866-418-21 ADAPTOR, AC (AC-T70) CORD (WITH MODULAR PLUG)(LINE) MANUAL, INSTRUCTION (ENGLISH,FRENCH) GUIDE, QUICK START (ENGLISH,FRENCH) 51 52 53 54 Sony Corporation 9-926-514-31 Personal & Mobile Communication Company – 16 – 99D0902042-1 Printed in Japan © 1999. 4 Published by Quality Assurance Dept.
