1
Download Lochinvar G936199 User's Manual
Transcript
CFII-22 Replacement Parts List ® Copper-Fin II PARTS DEPOT Nashville, Tennessee 615-889-8900 • Fax: 615-547-1000 www.Lochinvar.com Boilers — Water Heaters & Pool Heaters CH—CF—CP — 990-2070 Beginning Serial Number: G936199 to Present - 13 34 14 19 33 32 27 29 20 31 30 28 4 12 RPL 7007 Control Panel 7 23 22 11 15 24 10 9 6 8 Heat Exchanger Assembly 18 16 21 17 26 Gas Train 25 3 2 ITEM NO. PART NO. DESCRIPTION MODEL NO. Gas Train Assemblies 1 BNR3410 BNR3411 BNR3412 BNR3413 BNR3414 KIT # 990 1260 1440 1800 2070 BNR2404: 9ea. 12ea. 14ea. 17ea. 20ea. BNR3501: 1ea. 1ea. 1ea. 1ea. 1ea. BNR3502: 1ea. 1ea. 1ea. 2ea. 2ea. BNR2404 is Main Burner BNR3501 is Main Burner Connected Thermocouple Compression Fitting BNR3502 is Main Burner w/ Pressure Tap, Barbed Fitting ALL ALL ALL ALL 4 4 5 5 ORF2413 ORF2405 VAL3403 VAL3404 ORIFICE, NAT. ORIFICE, LPG. VALVE, GAS NAT. VALVE, GAS LPG. 6 6 --7 8 --9 10 11 11 ---12 13 14 -15 ------ HLC2701 HLC2702 MSC2420 MSC2447 PAN3000 PAN3001 MSC2448 MSC2449 RLY3002 RLY3003 TST3004 TST3006 WRE2416 HLC2503 HLC2501 PLT3400 PRS2416 PRS2417 PRS2406 TRF2701 WTR2041 MSC2426 MSC2706 MSC2461 MSC2406 HIGH LIMIT HIGH LIMIT MANUAL RESET TERMINAL STRIP 6 POLE CIRCUIT BREAKER 7 AMP. CONTROL PANEL COMPLETE LIGHT ASSEMBLY W/FRONT ESCUTCHEON LIGHT, INDICATOR 120V. LIGHT, INDICATOR 28V. IGNITION MODULE TIME DELAY MODULE ELECTRONIC THERMOSTAT CONTROL ELECT. THERMOSTAT CONTROL, W/INDOOR/OUTDOOR SENSORS SENSOR 110º HI LIMIT (POOL PIPING) 200º HI LIMIT (OUTLET SIDE) BEGINNING SERIAL # A980000 HOT SURFACE IGNITOR PRESSURE SWITCH, DUAL PRESSURE SWITCH, LOW AIR PRESSURE SWITCH, POOL HEATER TRANSFORMER 150V.A. SWITCH, FLOW OUTDOOR SWITCH, MAIN POWER TUBING, EDPM 1/4" (ORDER BY THE FOOT) TUBING, SILICONE (ORDER BY THE FOOT) TUBING, EDPM 1/8" (ORDER BY THE FOOT) 16 17 17 17 17 17 17 17 17 17 17 18 18 18 18 18 35 35 35 35 35 36 GKT2418 HEX3420 HEX3421 HEX3422 HEX3423 HEX3424 HEX3000 HEX3001 HEX3002 HEX3003 HEX3004 JKE6078 JKE6079 JKE6080 JKE6081 JKE6082 JKE6159 JKE6160 JKE6161 JKE6162 JKE6163 JKD6187 GASKET, HEAT SHIELD HEAT EXCHANGER H (CF & CP before serial HEAT EXCHANGER H (CF & CP before serial HEAT EXCHANGER H (CF & CP before serial HEAT EXCHANGER H (CF & CP before serial HEAT EXCHANGER H (CF & CP before serial HEAT EXCHANGER HLW (After Serial # F00) HEAT EXCHANGER HLW (After Serial # F00) HEAT EXCHANGER HLW (After Serial # F00) HEAT EXCHANGER HLW (After Serial # F00) HEAT EXCHANGER HLW (After Serial # F00) V-BAFFLE (9 PER UNIT) V-BAFFLE (9 PER UNIT) V-BAFFLE (9 PER UNIT) V-BAFFLE (9 PER UNIT) V-BAFFLE (9 PER UNIT) V-BAFFLE FRAME RUNNER V-BAFFLE FRAME RUNNER V-BAFFLE FRAME RUNNER V-BAFFLE FRAME RUNNER V-BAFFLE FRAME RUNNER V-BAFFLE FRAME END Controls & Gauges CF CH ALL ALL ALL ALL ALL ALL ALL ALL ALL OPTIONAL ALL CP ALL ALL ALL CP ALL CF/CH ALL ALL ALL ALL Heat Exchangers * "CONSULT FACTORY" NOTE: CH = BOILER, CF = WATER HEATER & CP = POOL HEATER 3 F00 F00 F00 F00 F00 & All & All & All & All & All CH) CH) CH) CH) CH) ALL 990 1260 1440 1800 2070 CF/CP990 CF/CP1260 CF/CP1440 CF/CP1800 CF/CP2070 990 1260 1440 1800 2070 990 1260 1440 1800 2070 ALL ITEM NO. PART NO. DESCRIPTION MODEL NO. Miscellaneous 19 -20 21 21 22 23 24 25 25 25 26 FAN2714 GTP2900 MSC3415 RLV2001 RLV2007 RLY2425 RLY2424 RLY2706 ARM3024PBF ARM3024PAB ARM3024PABTE RLY2041 TST2301 FAN ASSEMBLY PRESSURE TEMPERATURE GAUGE SIGHT GLASS & GASKET RELIEF VALVE, PRESSURE ONLY RELIEF VALVE, TEMPERATURE & PRESSURE RELAY 120 VOLT RELAY 24 VOLT RELAY, POWER PUMP (Before Serial # L01) PUMP (After Serial # L01 Standard) PUMP PUMP DELAY RELAY WELL, THERMOSTAT 27 27 27 27 27 27 27 27 27 28 28 28 28 28 28 29 29 29 29 29 29 30 30 30 30 30 30 30 30 31 32 33 FIB2441 FIB2442 FIB2443 FIB2444 FIB2445 FIB2446 FIB2447 FIB2448 FIB2449 FIB2471 FIB2450 FIB2451 FIB2452 FIB2453 FIB2454 FIB2472 FIB2455 FIB2456 FIB2457 FIB2458 FIB2459 FIB2460 FIB2461 FIB2462 FIB2469 FIB2463 FIB2470 FIB2464 FIB2465 FIB2466 FIB2467 FIB2468 LOCH-HEAT TILE, TOP RIGHT SIDE LOCH-HEAT TILE, TOP LEFT SIDE LOCH-HEAT TILE, TOP RIGHT SIDE LOCH-HEAT TILE, TOP LEFT SIDE LOCH-HEAT TILE, TOP LEFT SIDE LOCH-HEAT TILE, TOP RIGHT SIDE LOCH-HEAT TILE, TOP MIDDLE LOCH-HEAT TILE, TOP LEFT SIDE LOCH-HEAT TILE, TOP LEFT SIDE LOCH-HEAT TILE, BOTTOM LOCH-HEAT TILE, BOTTOM RIGHT LOCH-HEAT TILE, BOTTOM LOCH-HEAT TILE, BOTTOM LEFT LOCH-HEAT TILE, BOTTOM LEFT LOCH-HEAT TILE, BOTTOM LEFT LOCH-HEAT TILE, BACK LOCH-HEAT TILE, BACK RIGHT LOCH-HEAT TILE, BACK LOCH-HEAT TILE, BACK LEFT LOCH-HEAT TILE, BACK LEFT LOCH-HEAT TILE, BACK LEFT LOCH-HEAT TILE, FRONT DOOR LOCH-HEAT TILE, FRONT DOOR LOCH-HEAT TILE, FRONT DOOR RIGHT LOCH-HEAT TILE, FRONT DOOR LEFT LOCH-HEAT TILE, FRONT DOOR RIGHT LOCH-HEAT TILE, FRONT DOOR LEFT LOCH-HEAT TILE, FRONT DOOR RIGHT LOCH-HEAT TILE, FRONT DOOR LEFT LOCH-HEAT TILE, FRONT HEAD SIDE LOCH-HEAT TILE, REAR HEAD SIDE LOCH-HEAT TILE, REAR HEAD SPACER STRIP ALL CH ALL CH CF ALL ALL ALL CF CF CP CF ALL Loch-Heat® Tile 990 990 1260-1440 1260 1440 1800-2070 1800-2070 1800 2070 990 1440-2070 1260 1440 1800 2070 990 1440-2070 1260 1440 1800 2070 990 1260 1440 1440 1800 1800 2070 2070 ALL ALL ALL Optional 3 GAC2031 3 GAC2032 34 PAN3401 34 PAN3402 34 PAN3403 Have - PLEASE: FAN2013 model GAS COCK GAS COCK OPTION BOX A: LOUVER RELAYw/PUMP DELAY (LVRw/P. DELAY) OPTION BOX B: MR-LWCO, LVRw/P. DELAY OPTION BOX C: MR-LWCO, LVRw/P. DELAY, ALM. ANY FAILURE number and serial when ordering parts PROVING SWITCH FORnumber HS5 4 990 & 1260 1440-2070 ALL ALL ALL ALL CP—5M—03/03—Pinted in U.S.A.
