Download Ice-O-Matic ICEU305**2 User's Manual
Transcript
SERVICE PARTS MANUAL The ICE Series Undercounter Cubers MODEL-ICEU300**2, ICEU305**2 Ice-O-Matic 11100 East 45th A Ave e Denver, Colorado 80239 Part Number 9081332-02 Print Date 1/09 * ICEU300**2 Service Parts Table of Contents This parts list contains the service parts available for the ICEU300**2 Undercounter icemakers. Check the model number on the data plate and refer to the correct listing for the specific component. Check carefully that the correct part is identified and ordered. Table of Contents Page 1 Bin and Exterior Components Page 2 - 3 Refrigeration System Page 4 - 5 Harvest Assist Assembly Page 6 Control Box Page 7 Evaporator Page 8 Water Pump Page 9 Note: ** Denotes condenser and cube size Ice-O-Matic 11100 East 45th Ave. Denver Co. 80239 800-423-3367 Page 1 ICEU300**2 Service Parts Bin and Exterior Components Page 2 ICEU300**2 Service Parts Item ICEU300 1 3021895-01 2 3051895-02 3 3012149-01 4 9151015-04 5 9101242-01 6 9051530-01 7 9051531-01 8 2101400-01S 9 9031112-01 10 9091122-02 11 9021010-04 12 2101434-01S 9051525-04 9031122-03 3013235-01 13 2101429-01S 9051573-02 9051573-01 9031098-02 14 9031023-10 15 9031046-03 16 9031162-01 17 3013161-01 18 9021001-03 19 9051127-02 20 2021646-01 21 3021883-01 22 3021883-01 23 9091140-01 24 N/A 25 N/A ICEU305 3021895-01 3051895-02 3012149-01 N/A N/A 9051530-01 9051531-01 2101400-01S 9031112-01 9091122-02 9021010-04 2101434-01S 9051525-04 9031122-03 3013235-01 2101429-01S 9051573-02 9051573-01 9031098-02 9031023-10 9031046-03 9031162-01 3013221-01 9021001-03 9051127-02 2021646-01 3021883-01 3021883-01 9091140-01 3013242-01 3013241-01 Bin and Exterior Components Description Trim Strip RH Trim Strip LH Panel Rear Access Bushing, Strain Relief Power Cord 115 Volt Only Front Grill Large Front Grill Small Bin Assembly (Includes Item 10) Hex Head Machine Screw Drain Elbow Clamp Bin Door Assembly Bin Door Thumb Screw Door Stop Bin Top Assembly Stainless Steel Plastic Corner Cap Left Side Plastic Corner Cap Right Side Truss Head Sheet Metal Screw-Plastic Corner Top Panel Screw Screw Bin Fastener Thumb Nut Three Prong Control Box Cover Leg Set (4 each) Ice Scoop Rear Panel Left Side Panel Right Side Panel Plastic Drain Fitting Water Pump Cover Cover Base Panel Page 3 ICEU300**2 Service Parts Refrigeration Page 4 ICEU300**2 Service Parts Item 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 ICEU300 9181121-01 9151134-04 9151004-02 9151004-05 9091086-02 9091086-03 9151123-06 9151123-03 9041086-04 9031004-02 9181002-07 9031118-02 9181002-08 9031012-02 2021644-01 9141121-01 2101399-01 9031046-24 9031004-19 3013270-01 3013243-01 9161112-01 9131446-01 3013217-01 9141128-01 9021010-04 9091024-01 9091140-01 2021646-01 9041059-01 9091063-02 9091135-01 9031118-05 9041087-03 3021883-01 3021883-01 9101218-14 2041338-01 ICEU305 9181122-01 9151134-04 9151004-02 9151004-05 9091086-02 9091086-03 9151123-06 9151123-04 9041086-05 9031004-02 9181002-07 9031118-02 9181002-08 9031012-02 2021644-01 9141121-01 2101399-01 9031046-24 9031004-19 3013270-01 3013243-01 9161112-02 9131446-01 3013217-01 9141128-01 9021010-04 9091024-01 9091140-01 2021646-01 9041059-01 9091063-02 9091135-01 9031118-05 9041087-03 3021883-01 3021883-01 9101218-14 2041338-01 Compressor Components ICEU300 ICEU305 9181121-01 9181122-01 9181005-37 9181005-39 9181003-39 9181003-40 9181004-27 9181010-26 N/A 9181009-08 Refrigeration Description Compressor Expansion Valve Drier-Air Cooled Drier-Water Cooled Service Valve Core Service Valve Cap Hot Gas Valve Body Hot Gas Valve Coil Purge Valve Flat Washer Grommet Lock Nut Sleeve Compressor Mounting Lock Nut (Leg) Base Assembly Water Condenser Water Trough Assembly Water Trough Screws Rubber Washer Water Trough Support Bracket Fan Bracket Fan Motor Fan Blade Fan Shroud Air Condenser Hose Clamp Barbed Tee Drain Fitting Rear Panel Water Regulator Drop Adapter Fitting Water Inlet Fitting Flanged Lock Nut High Temperature Safety Control Side Panel S/S Side Panel S/S Water Pump Connector Water Distribution Tube Description Compressor Overload Start Capacitor Compressor Relay Run Capacitor Page 5 ICEU300**2 Service Parts Item 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 ICEU300 2061962-05 3013170-01 9161030-01 9131190-03 9051001-13 9051001-03 9031019-08 9051057-01 9021102-01 9031003-03 9031119-01 9051519-01 9101160-01 3051145-02 9031008-44 9031120-01 ICEU305 2061962-07 3013170-01 9161031-01 9131190-03 9051001-13 9051001-03 9031019-08 9051057-01 9021102-01 9031003-03 9031119-01 9051519-01 9101160-01 3051145-02 9031008-44 9031120-01 Harvest Assist Assembly Description Harvest Assist Assembly Bracket, Probe Motor Gear Motor Clutch Assembly, 60 Degree Snap Bushing Snap Bushing #6-32 x 1/2 Screw Connecting Rod Probe, Single Length Flat Washer Shoulder Screw Spacer, Cam Switch Cam Switch Insulator Pan Head Screw Speed Nut Plate Page 6 ICEU300**2 Service Parts Item 1 2 3 4 5 6 7 8 9 10 11 12 13 ICEU300 9041097-01 9101195-01 9101139-03 9041095-01 9041094-01 N/A 9181003-39 9181004-27 9101148-01 9041087-03 9101084-01 9101083-01 9041083-02 ICEU305 9041097-01 9101195-01 9101139-03 9041095-01 9041094-01 9181009-08 9181003-40 9181010-26 9101148-01 9041087-03 9041084-02 9101083-01 9041083-02 Control Box Description Thermostat-Bin Control Ice/Off/Wash Switch Switch-Purge High Pressure Control Low Pressure Control (Timer Initiate) Run Capacitor Start Capacitor Relay Timing Module High Temperature Safety Control Relay Socket-Relay Hold Down Spring - Relay Page 7 ICEU300**2 Service Parts Item 1 1 2 3 4 5 6 7 8 ICEU300 2051231-82 2051231-81 2041338-01 9031122-01 9031004-19 9051135-05 9051136-07 9051136-08 9051135-04 ICEU305 2051231-82 2051231-81 2041338-01 9031122-01 9031004-19 9051135-05 9051136-07 9051136-08 9051135-04 Evaporator Description Evaporator Assembly-Half Cube (Shown) Evaporator Assembly-Full Cube Water Distribution Tube Thumbscrew Rubber Washer Spillway Left Side Evaporator Mounting Panel Right Side Evaporator Mounting Panel Water Return Page 8 ICEU300**2 Service Parts Item 1 2 3 4 5 6 7 8 9 10 11 12 13 ICEU300 9161076-01 3013219-01 9031141-01 9131111-01 6021032-01 9091080-01 9091081-01 9131026-02 3051223-02 9021010-04 9091024-01 9021010-03 9051280-05 ICEU305 9161076-02 3013219-01 9031141-01 9131111-01 6021032-01 9091080-01 9091081-01 9131026-02 3051223-02 9021010-04 9091024-01 9021010-03 9051280-05 Water Pump Description Water Pump Pump Bracket Plastic Nut Float Tube-Polyethylene - 11 Inches Required Barrel Fitting Sleeve Cap Plug Hose PVC 5/8 - 2.00 Inch Required Plastic Clamp Barbed Tee Plastic Clamp Drain Tube Page 9