1
Download Cornelius Nordic CCM1448 User's Manual
Transcript
IMI CORNELIUS INC. www.cornelius.com Nordic Model CCM1448, 1848, 2148 Service Parts Manual (Includes 50Hz. Units) Publication Number: 631806060 Revision Date: November 1, 2007 Revision: A Visit the IMI Cornelius web site at www.cornelius.com for all your Literature needs. CCM1448-CCM2148 Service Parts Manual Manual Number 631806060 * CCM Series Service Parts Table of Contents This parts list contains the service parts available for the CCM Series icemakers listed below. CCM1448 Air, Water and Remote, Includes 50hz. And 3 phase models. CCM1848 Water and Remote, Includes 50hz. And 3 phase models. CCM2148 Water and Remote, Includes 50hz. And 3 phase models. Check the model number on the data plate and refer to the correct listing for the specific component. Check carefully that the correct part is identified and ordered. Table of Contents Page 1 Exterior Components Page 2 - 3 Interior Components-Front View Page 4 - 5 Air Cooled Page 6 - 7 Water Cooled Page 8 - 9 Remote Page 10 - 11 Control Box Page 12 - 13 Specific Compressor Components Page 13 Harvest Assist Assembly Page 14 - 15 Remote Condenser Page 16 - 17 Water Pump and Float Page 18 - 19 Compressor Information Page 20 E-Mail: [email protected] Website : www.cornelius.com Telephone Number 800-238-3600 All Departments The CCM Series Service Manual is available seperately, Part Number 631806061 Note: Model Number Suffix Indicates Machine Voltage As Follows: 1=115/60/1 2=208-230/60/1 3=208-230/60/3 5=230/50/1 Page 1 CCM Series Service Parts Exterior Components Page 2 CCM Series Service Parts Item No. 1 2 3 4 5 6 7 8 9 10 11 12 13 Item No. 1 2 3 4 5 6 7 8 9 10 11 12 13 CCM1848 2 620204772 620204444 620204773 620204774 N/A 620204384 620204442 620204457 N/A 620204385 620204386 620204441 620204330 Model Number CCM1848 3 CCM2148 2 620204772 620204772 620204444 620204444 620204773 620204773 620204774 620204774 N/A N/A 620204384 620204384 620204442 620204442 620204457 620204457 N/A N/A 620204385 620204385 620204386 620204386 620204441 620204441 620204330 620204330 CCM1448 5 620204772 620204444 620204773 620204774 620204775 620204384 620204776 620204457 620204777 620204385 620204386 620204441 620204330 Model Number CCM1448 2 620204772 620204444 620204773 620204774 620204775 620204384 620204776 620204457 620204777 620204385 620204386 620204441 620204330 Exterior Components CCM2148 3 620204772 620204444 620204773 620204774 N/A 620204384 620204442 620204457 N/A 620204385 620204386 620204441 620204330 Description Top Panel Top Panel Screw Front Panel Front Panel Screw Left Hand Side Panel-Louvered Left Hand Side Panel-Solid Side Panel Screws Plastic Nut Insert Right Hand Side Panel-Louvered Right Hand Side Panel-Solid Rear Panel Rear Panel Screw Ice Deflector CCM1448 3 620204772 620204444 620204773 620204774 620204775 620204384 620204776 620204457 620204777 620204385 620204386 620204441 620204330 Description Top Panel Top Panel Screw Front Panel Front Panel Screw Left Hand Side Panel-Louvered Left Hand Side Panel-Solid Side Panel Screws Plastic Nut Insert Right Hand Side Panel-Louvered Right Hand Side Panel-Solid Rear Panel Rear Panel Screw Ice Deflector Page 3 CCM Series Service Parts Front Interior ICE P USH TO P URGE OFF WASH ICE P USH TO P URGE OFF WASH Page 4 CCM Series Service Parts Item No. 1 2 3 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 Item No. 1 2 3 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 CCM1848 2 620204778 620204345 620204298 620204299 620204409 620204295 620204294 620204453 620204429 620204420 620204499 620204500 620204496 620204443 620204534 620204535 620204467 620204457 620204441 620204554 620204573 Model Number CCM1848 3 CCM2148 2 620204778 620204778 620204345 620204345 620204298 620204298 620204299 620204299 620204409 620204409 620204295 620204295 620204294 620204294 620204453 620204453 620204429 620204429 620204420 620204420 620204499 620204499 620204500 620204500 620204496 620204496 620204443 620204443 620204534 620204534 620204535 620204535 620204467 620204467 620204457 620204457 620204441 620204441 620204554 620204554 620204573 620204573 CCM1448 5 620204778 620204345 620204302 620204303 620204408 620204295 620204294 620204453 620204429 620204420 620204499 620204500 620204497 620204443 620204534 620204535 620204467 620204457 620204441 620204554 620204573 Model Number CCM1448 2 620204778 620204345 620204302 620204303 620204408 620204295 620204294 620204453 620204429 620204420 620204499 620204500 620204497 620204443 620204534 620204535 620204467 620204457 620204441 620204554 620204573 Front Interior CCM2148 3 620204778 620204345 620204298 620204299 620204409 620204295 620204294 620204453 620204429 620204420 620204499 620204500 620204496 620204443 620204534 620204535 620204467 620204457 620204441 620204554 620204573 Description Left Hand Frame Panel Right Hand Frame Panel Evaporator-Full Cube Evaporator-Half Cube Evaporator Splash Curtain Water Distribution Tube LH Water Distribution Tube RH Thumb Screw Rubber Washer Clamp Tube Washer Washer Tapered Water Return Trough Water Return Trough Screw Valve Core Valve Cap Purge Valve Plastic Nut Insert Evaporator Mounting Screw Bin Switch Wire-Curtain Switch CCM1448 3 620204778 620204345 620204302 620204303 620204408 620204295 620204294 620204453 620204429 620204420 620204499 620204500 620204497 620204443 620204534 620204535 620204467 620204457 620204441 620204554 620204573 Description Left Hand Frame Panel Right Hand Frame Panel Evaporator-Full Cube Evaporator-Half Cube Evaporator Splash Curtain Water Distribution Tube LH Water Distribution Tube RH Thumb Screw Rubber Washer Clamp Tube Washer Washer Tapered Water Return Trough Water Return Trough Screw Valve Core Valve Cap Purge Valve Plastic Nut Insert Evaporator Mounting Screw Bin Switch Wire-Curtain Switch Page 5 CCM Series Service Parts Air Cooled Page 6 CCM Series Service Parts Item No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 CCM1448 5 620204779 620204614 620204611 620204476 620204602 620204530 620204533 620204813 620204422 620204616 620204502 620204418 620204419 620204470 620204780 620204636 620204577 620204286 620204358 Model Number CCM1448 2 620204690 620204614 620204611 620204476 620204602 620204530 620204533 620204813 620204422 620204617 620204502 620204418 620204419 620204470 620204780 620204641 620204574 620204335 620204358 Air Cooled CCM1448 3 620204691 620204614 620204611 620204476 620204602 620204530 620204533 620204813 620204422 620204617 620204502 620204418 620204419 620204470 620204780 620204641 620204574 620204335 620204358 Page 7 Description Compressor Hot Gas Valve Coil Hot Gas Valve Body Low Pressure Control Filter Drier Drop Adapter Water Inlet Fitting Purge Drain Fitting Clamp-TXV Bulb Expansion Valve Purge Drain Tube Tube ( 3.59 Ft.) Clamp High Temp Safety Air Condenser Fan Motor Fan Blade Fan Motor Bracket Fan Shroud CCM Series Service Parts Water Cooled CCM1848/2148 Water Cooled Machine Shown Page 8 CCM Series Service Parts Item No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 Item No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 CCM1848 2 620204690 620204614 620204611 620204476 620204602 620204530 620204533 620204813 620204422 620204620 620204502 620204418 620204419 620204470 620204597 620204464 620204529 620204297 CCM1848 3 620204691 620204614 620204611 620204476 620204602 620204530 620204533 620204813 620204422 620204620 620204502 620204418 620204419 620204470 620204597 620204464 620204529 620204297 CCM2148 2 620204701 620204614 620204611 620204476 620204602 620204530 620204533 620204813 620204422 620204620 620204502 620204418 620204419 620204470 620204597 620204464 620204529 620204297 Water Cooled Model Number CCM2148 3 Description 620204702 Compressor 620204614 Hot Gas Valve Coil 620204611 Hot Gas Valve Body 620204476 Low Pressure Control 620204602 Filter Drier 620204530 Drop Adapter 620204533 Water Inlet Fitting 620204813 Purge Drain Fitting 620204422 Clamp-TXV Bulb 620204620 Expansion Valve 620204502 Purge Drain Hose 620204418 Tube ( 3.59 Ft.) 620204419 Clamp 620204470 High Temp Safety 620204597 Water Condenser 620204464 Water Valve 620204529 Drop Adapter 1/2" 620204297 Expansion Valve Assembly (Includes Distributor and Tubing) MODEL NUMBER CCM1448 5 CCM1448 2 CCM1448 3 620204779 620204690 620204691 620204614 620204614 620204614 620204612 620204612 620204612 620204474 620204474 620204474 620204602 620204602 620204602 620204530 620204530 620204530 620204533 620204533 620204533 620204813 620204813 620204813 620204422 620204422 620204422 620204616 620204617 620204617 620204502 620204502 620204502 620204418 620204418 620204418 620204419 620204419 620204419 620204470 620204470 620204470 620204587 620204587 620204587 620204465 620204465 620204465 620204529 620204529 620204529 Page 9 Description Compressor Hot Gas Valve Coil Hot Gas Valve Body Low Pressure Control Filter Drier Drop Adapter Water Inlet Fitting Purge Drain Fitting Clamp-TXV Bulb Expansion Valve Purge Drain Hose Tube ( 3.59 Ft.) Clamp High Temp Safety Water Condenser Water Valve Drop Adapter 1/2" CCM Series Service Parts Remote CCM1848/2148 Remote Machine Shown Page 10 CCM Series Service Parts Item No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 Item No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 CCM1848 2 620204690 620204614 620204611 620204476 620204602 620204530 620204533 620204813 620204422 620204620 620204417 620204418 620204419 620204470 620204612 620204614 620204609 620204297 620204605 620204526 620204527 620204331 620204474 620204475 620204324 Model Number CCM1848 3 CCM2148 2 620204691 620204701 620204614 620204614 620204611 620204611 620204476 620204476 620204602 620204602 620204530 620204530 620204533 620204533 620204813 620204813 620204422 620204422 620204620 620204620 620204417 620204417 620204418 620204418 620204419 620204419 620204470 620204470 620204612 620204612 620204614 620204614 620204609 620204609 620204297 620204297 620204605 620204605 620204526 620204526 620204527 620204527 620204331 620204331 620204474 620204474 620204475 620204475 620204324 620204324 CCM1448 5 620204779 620204614 620204611 620204476 620204602 620204530 620204533 620204813 620204422 620204781 620204417 620204418 620204419 620204470 620204612 620204614 620204610 N/A 620204605 620204526 620204527 620204331 620204474 620204475 Model Number CCM1448 2 620204690 620204614 620204611 620204476 620204602 620204530 620204533 620204813 620204422 620204617 620204417 620204418 620204419 620204470 620204612 620204614 620204610 N/A 620204605 620204526 620204527 620204331 620204474 620204475 Remote CCM2148 3 620204702 620204614 620204611 620204476 620204602 620204530 620204533 620204813 620204422 620204620 620204417 620204418 620204419 620204470 620204612 620204614 620204609 620204297 620204605 620204526 620204527 620204331 620204474 620204475 620204324 Description Compressor Hot Gas Valve Coil Hot Gas Valve Body Low Pressure Control Filter Drier Drop Adapter Water Inlet Fitting Purge Drain Fitting Clamp-TXV Bulb Expansion Valve Purge Drain Hose Tube ( 2.17 Ft.) Clamp High Temp Safety Liquid Line Solenoid Body Liquid Line Solenoid Coil Receiver Expansion Valve Assembly Mixing Valve (240) Remote Fitting 3/8" Remote Fitting 1/2" Rear Brace High Pressure Control Pump Down Control Accumulator/Heat Exchanger CCM1448 3 620204693 620204614 620204611 620204476 620204602 620204530 620204533 620204813 620204422 620204617 620204417 620204418 620204419 620204470 620204612 620204614 620204610 N/A 620204605 620204526 620204527 620204331 620204474 620204475 Description Compressor Hot Gas Valve Coil Hot Gas Valve Body Low Pressure Control Filter Drier Drop Adapter Water Inlet Fitting Purge Drain Fitting Clamp-TXV Bulb Expansion Valve Purge Drain Hose Tube ( 2.17 Ft.) Clamp High Temp Safety Liquid Line Solenoid Body Liquid Line Solenoid Coil Receiver Expansion Valve Assembly Mixing Valve (240) Remote Fitting 3/8" Remote Fitting 1/2" Rear Brace High Pressure Control Pump Down Control Page 11 CCM Series Service Parts Control Box Page 12 CCM Series Service Parts Item No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 Item No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 CCM1848 2 620204553 620204557 620204548 620204551 620204544 620204676 620204652 620204674 620204555 620204555 620204476 620204475 620204554 620204470 620204474 Model Number CCM1848 3 CCM2148 2 620204553 620204553 620204557 620204557 620204548 620204548 620204551 620204551 620204782 620204783 N/A 620204677 N/A 620204652 N/A 620204671 620204555 620204555 620204555 620204555 620204476 620204476 620204475 620204475 620204554 620204554 620204470 620204470 620204474 620204474 CCM1448 5 620204553 620204557 620204548 620204551 620204544 620204675 620204655 620204674 620204555 620204555 620204476 620204475 620204554 620204470 620204474 Model Number CCM1448 2 620204553 620204557 620204548 620204551 620204544 620204676 620204652 620204674 620204555 620204555 620204476 620204475 620204554 620204470 620204474 Control Box CCM2148 3 620204553 620204557 620204548 620204551 620204782 N/A N/A N/A 620204555 620204555 620204476 620204475 620204554 620204470 620204474 Description Purge Switch ON-OFF-WASH Switch Relay Socket Relay Contactor Compressor Start Relay Start Capacitor Run Capacitor Timer Timer (Set at 4 Seconds) Low Pressure Timer Initiate Pump Down Control Bin Switch High Temperature Safety Control High Pressure Safety Control CCM1448 3 620204553 620204557 620204548 620204551 620204782 N/A N/A N/A 620204555 620204555 620204476 620204475 620204554 620204470 620204474 Description Purge Switch ON-OFF-WASH Switch Relay Socket Relay Contactor Compressor Start Relay Start Capacitor Run Capacitor Timer Timer (Set at 4 Seconds) Low Pressure Timer Initiate Pump Down Control Bin Switch High Temperature Safety Control High Pressure Safety Control Page 13 CCM Series Service Parts Harvest Assist Assembly Page 14 CCM Series Service Parts Item No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 Item No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 CCM1848 2 620204366 620204631 620204571 620204483 620204481 620204439 620204484 620204424 620204427 620204451 620204516 620204556 620204407 620204434 620204452 620204313 Model Number CCM1848 3 CCM2148 2 620204366 620204366 620204631 620204631 620204571 620204571 620204483 620204483 620204481 620204481 620204439 620204439 620204484 620204484 620204424 620204424 620204427 620204427 620204451 620204451 620204516 620204516 620204556 620204556 620204407 620204407 620204434 620204434 620204452 620204452 620204313 620204313 CCM14485 620204366 620204631 620204571 620204483 620204481 620204439 620204484 620204424 620204427 620204451 620204516 620204556 620204407 620204434 620204452 620204313 Model Number CCM1448 2 620204366 620204631 620204571 620204483 620204481 620204439 620204484 620204424 620204427 620204451 620204516 620204556 620204407 620204434 620204452 620204313 Harvest Assist Assembly CCM2148 3 620204366 620204631 620204571 620204483 620204481 620204439 620204484 620204424 620204427 620204451 620204516 620204556 620204407 620204434 620204452 620204313 Description Bracket, Probe Motor Gear Motor Clutch Assembly .312 rad Snap Bushing Snap Bushing #6-32 x 1/2 Fillister Head Screw Connecting Rod Probe, Single Length Plain Flat Washer Shoulder Screw Spacer, Cam Switch Cam Switch Insulator, Switch Pan Head Machine Screw Speed Nut Plate Complete Assembly CCM1448 3 620204366 620204631 620204571 620204483 620204481 620204439 620204484 620204424 620204427 620204451 620204516 620204556 620204407 620204434 620204452 620204313 Description Bracket, Probe Motor Gear Motor Clutch Assembly .312 rad Snap Bushing Snap Bushing #6-32 x 1/2 Fillister Head Screw Connecting Rod Probe, Single Length Plain Flat Washer Shoulder Screw Spacer, Cam Switch Cam Switch Insulator, Switch Pan Head Machine Screw Speed Nut Plate Complete Assembly Page 15 CCM Series Service Parts Remote Condenser Page 16 CCM Series Service Parts Item No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 Item No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 CCM1848 2 RC18002 620204784 620204576 620204642 620204643 620204342 620204575 620204785 620204786 620204787 620204788 620204791 620204792 620204341 620204525 620204523 620204524 620204522 Model Number CCM1848 3 CCM2148 2 RC18002 RC21002 620204784 620204592 620204576 620204576 620204642 620204642 620204643 620204643 620204342 620204342 620204575 620204575 620204785 620204789 620204786 620204790 620204787 620204787 620204788 620204788 620204791 620204791 620204792 620204792 620204341 620204341 620204525 620204525 620204523 620204523 620204524 620204524 620204522 620204522 CCM1448 5 RC14002 620204590 620204576 620204642 620204643 620204342 620204575 620204793 620204794 620204787 620204788 620204791 620204792 620204341 620204525 620204523 620204524 620204522 Model Number CCM1448 2 RC14002 620204590 620204576 620204642 620204643 620204342 620204575 620204793 620204794 620204787 620204788 620204791 620204792 620204341 620204525 620204523 620204524 620204522 Remote Condenser CCM2148 3 RC21002 620204592 620204576 620204642 620204643 620204342 620204575 620204789 620204790 620204787 620204788 620204791 620204792 620204341 620204525 620204523 620204524 620204522 Description Condenser Fan Blade Fan Motor Capacitor Fan Motor Brace Fan Guard Top Panel Side Panel Front Panel Rear Panel Coupling Half-Bulkhead-1/2" Coupling Half-Bulkhead-3/8" Mounting Leg Lineset Fitting with Port 1/2" Lineset Fitting with Port 3/8" Lineset Fitting without Port 1/2" Lineset Fitting without Port 3/8" CCM1448 3 RC14002 620204590 620204576 620204642 620204643 620204342 620204575 620204793 620204794 620204787 620204788 620204791 620204792 620204341 620204525 620204523 620204524 620204522 Description Condenser Fan Blade Fan Motor Capacitor Fan Motor Brace Fan Guard Top Panel Side Panel Front Panel Rear Panel Coupling Half-Bulkhead-1/2" Coupling Half-Bulkhead-3/8" Mounting Leg Lineset Fitting with Port 1/2" Lineset Fitting with Port 3/8" Lineset Fitting without Port 1/2" Lineset Fitting without Port 3/8" Page 17 CCM Series Service Parts Water Pump and Float Page 18 CCM Series Service Parts Item No. 1 2 3 4 5 6 7 8 9 10 Item No. 1 2 3 4 5 6 7 8 9 10 CCM1848 2 620204346 620204565 620204563 620204532 620204531 620204418 620204507 620204420 620204637 620204457 Model Number CCM18483 CCM2148 2 620204346 620204346 620204565 620204565 620204563 620204563 620204532 620204532 620204531 620204531 620204418 620204418 620204507 620204507 620204420 620204420 620204637 620204637 620204457 620204457 CCM1448 5 620204346 620204565 620204563 620204532 620204531 620204418 620204795 620204420 620204637 620204457 Model Number CCM1448 2 620204346 620204565 620204563 620204532 620204531 620204418 620204795 620204420 620204637 620204457 Water Pump and Float CCM2148 3 620204346 620204565 620204563 620204532 620204531 620204418 620204507 620204420 620204637 620204457 Description Pump Bracket Float Assembly Cap Plug Sleeve Barrel Fitting Tube- Polyethylene (3.59 Ft.) Water Pump Tube Hose Clamp Water Pump Plastic Nut #10 CCM1448 3 620204346 620204565 620204563 620204532 620204531 620204418 620204795 620204420 620204637 620204457 Description Pump Bracket Float Assembly Cap Plug Sleeve Barrel Fitting Tube- Polyethylene (3.59 Ft.) Water Pump Tube Hose Clamp Water Pump Plastic Nut #10 Page 19 CCM Series Service Parts Compressor Data Compressor Components Model Number CCM1448 2 CCM1848 2 620204690 620204652 620204674 620204676 Compressor Start Capacitor Run Capacitor Relay CCM1448 5 620204779 620204655 620204674 620204675 Compressor Start Capacitor Run Capacitor Relay CCM1448 3 620204693 N/A N/A N/A Compressor Start Capacitor Run Capacitor Relay 620204691 N/A N/A N/A Compressor Start Capacitor Run Capacitor Relay CCM2148 2 620204701 620204652 620204671 620204677 Compressor Start Capacitor Run Capacitor Relay CCM2148 3 620204691 N/A N/A N/A Compressor Start Capacitor Run Capacitor Relay CCM1848 3 Page 20
