1
Download Cornelius CCM0830 User's Manual
Transcript
IMI CORNELIUS INC. www.cornelius.com Nordic Model CCM0830 1, 1030 1 Service Parts Manual (Includes 50Hz. Units) Publication Number: 631806064 Revision Date: October 1, 2008 Revision: A Visit the IMI Cornelius web site at www.cornelius.com for all your Literature needs. CCM0830 1-CCM1030 1 Service Parts Manual Manual Number 631806064 SERVICE PARTS MANUAL 22 INCH WIDE ICE SERIES CUBERS MODEL-ICE0320, ICE0520 Includes 50Hz. Units ICE-O-Matic 11100 East 45th Ave Denver, Colorado 80239 Part Number 9081297-01 PD04/02 Rev1/05 CCM Series Service Parts Table Of Contents This parts list contains the service parts available for the CCM Series icemakers listed below: CCM0830*21 Air, Water and Remote CCM0830*51 Air, Water and Remote CCM1030*21 Air, Water and Remote CCM1030*51 Air, Water and Remote Check the model number on the data plate and refer to the correct listing for the specific component. Check carefully that the correct part is identified and ordered. Table of Contents Page 1 Cabinet Assembly Page 2 - 3 Evaporator/Water System Page 4 - 5 Air Cooled Page 6 - 7 Water Cooled Page 8 - 9 Remote Page 10 - 11 Control Box Page 12 - 13 Specific Compressor Components Page 13 Harvest Assist Assembly Page 14 - 15 Remote Condenser Page 16 - 17 Telephone Number 800-238-3600 All Departments E-Mail: [email protected] Website: www.cornelius.com The CCM Series Service Manual is available separately, Part Number 631806061 Note: Model Number Suffix Indicates Machine Voltage As Follows 1=115/60/1 2=208-230/60/1 3=208-230/60/3 5=230/50/1 Engineering Revision Level =1 Page 1 CCM Series Service Parts Cabinet Assembly Page 2 CCM Service Parts Item No. CCM0830 5 1 1 620204811 2 620204774 3 620204457 4 620204930 5 620204884 6 620204776 7 620204809 620204810 8 620204444 9 620204337 10 620204885 11 620204382 12 620204441 13 620204349 14 620204347 15 620204929 Model Number CCM0830 2 1 CCM1030 5 1 620204811 620204811 620204774 620204774 620204457 620204457 620204930 620204930 620204884 620204884 620204776 620204776 620204809 620204809 620204810 620204810 620204444 620204444 620204337 620204337 620204885 620204885 620204382 620204382 620204441 620204441 620204349 620204349 620204347 620204347 620204929 N/A Exterior Panels CCM1030 2 1 620204811 620204774 620204457 620204930 620204884 620204776 620204809 620204810 620204444 620204337 620204885 620204382 620204441 620204349 620204347 N/A Description Front Panel Front Panel Screws Plastic Nut Right Hand Side Panel-Air Cooled Only Right Hand Side Panel-Water and Remote Only Side Panel Screws Top Panel, Air Cooled Top Panel, Water Cooled and Remote Top Panel Screws Rear Brace Left Hand Side Panel Rear Panel Rear Panel Screws Control Box Top Cover Control Box Side Cover Machine Compartment Cover Page 3 CCM Series Service Parts Evaporator/Water System Page 4 CCM Series Service Parts Item No. CCM0830 5 1 1 620204873 1 620204874 2 620204294 3 620204453 4 620204429 5 N/A 6 620204494 7 620204486 8 620204495 9 620204869 10 620204493 11 620204521 12 620204443 13 620204564 14 620204563 15 620204638 16 620204420 17 620204420 18 620204508 19 620204404 20 620204533 21 620204530 22 620204466 23 620204420 24 620204928 25 620204419 26 620204813 Model Number CCM0830 2 1 CCM1030 5 1 620204873 620204873 620204874 620204874 620204294 620204294 620204453 620204453 620204429 620204429 N/A N/A 620204494 620204494 620204486 620204486 620204495 620204495 620204869 620204869 620204493 620204493 620204521 620204521 620204443 620204443 620204564 620204564 620204563 620204563 620204638 620204638 620204420 620204420 620204420 620204420 620204508 620204508 620204404 620204404 620204533 620204533 620204530 620204530 620204466 620204466 620204420 620204420 620204928 620204928 620204419 620204419 620204813 620204813 Evaporator/Water System CCM1030 2 1 620204873 620204874 620204294 620204453 620204429 N/A 620204494 620204486 620204495 620204869 620204493 620204521 620204443 620204564 620204563 620204638 620204420 620204420 620204508 620204404 620204533 620204530 620204466 620204420 620204928 620204419 620204813 Description Evaporator Full Cube Evaporator Half Cube Water Distribution Tube Thumb Screw Rubber Washer Curtain Stopper Evaporator Mounting Panel Right Side Evaporator Water Return Evaporator Mounting Panel Left Side Evaporator Spillway Evaporator Splash Curtain Water Return Trough Water Return Trough Screw Float Caplug (Float Deflector) Water Pump Clamp Clamp Water Pump Tube Water Float Tubing (26 Inches required) Water Inlet Fitting Drop Adapter Purge Valve Clamp Purge Drain Hose Clamp Purge Drain Fitting Page 5 CCM Series Service Parts Air Cooled Page 6 CCM Series Service Parts Item No. CCM0830 5 1 1 620204688 2 620204612 3 620204614 4 620204476 5 620204603 6 620204534 7 620204535 8 620204596 9 620204478 10 620204882 11 620204924 12 620204814 13 620204577 14 620204636 15 620204286 16 620204480 17 620204926 18 620204927 19 620204458 Model Number CCM0830 2 1 CCM1030 5 1 620204686 620204685 620204612 620204612 620204614 620204614 620204476 620204476 620204603 620204603 620204534 620204534 620204535 620204535 620204596 620204596 620204478 620204478 620204882 620204882 620204924 620204924 620204814 620204814 620204574 620204577 620204641 620204636 620204335 620204286 620204480 620204480 620204926 620204926 620204927 620204927 620204458 620204458 Air Cooled CCM1030 2 1 620204687 620204612 620204614 620204476 620204603 620204534 620204535 620204596 620204478 620204882 620204924 620204814 620204812 620204641 620204335 620204480 620204926 620204927 620204458 Description Compressor Kit Hot Gas Valve Body Hot Gas Valve Coil Low Pressure Control Filter Drier Service Valve Core Service Valve Cap Condenser Fan Control Expansion Valve Insulation-Danfoss Expansion Valve Fan Shroud Fan Blade Fan Motor Fan Motor Bracket High Temperature Safety Control Insulation Panel Bottom Insulation Panel Top Divider Insulation Clip Note: The CCM0830 series has 1 fan motor, the CCM1030 series has 2 fan motors. Page 7 CCM Series Service Parts Water Cooled Page 8 CCM Series Service Parts Item No. CCM0830 5 1 1 620204688 2 620204883 3 620204614 4 620204476 5 620204602 6 620204534 7 620204535 8 620204587 9 620204465 10 620204474 11 620204882 12 620204924 13 620204480 14 620204925 15 620204926 16 620204927 17 620204458 Model Number CCM0830 2 1 CCM1030 5 1 620204686 620204685 620204883 620204883 620204614 620204614 620204476 620204476 620204602 620204602 620204534 620204534 620204535 620204535 620204587 620204587 620204465 620204465 620204474 620204474 620204882 620204882 620204924 620204924 620204480 620204480 620204925 620204925 620204926 620204926 620204927 620204927 620204458 620204458 Water Cooled CCM1030 2 1 620204687 620204883 620204614 620204476 620204602 620204534 620204535 620204587 620204465 620204474 620204882 620204924 620204480 620204925 620204926 620204927 620204458 Description Compressor Hot Gas Valve Body Hot Gas Valve Coil Low Pressure Control Filter Drier Service Valve Core Service Valve Cap Condenser Water Valve High Pressure Control Expansion Valve Insulation-Danfoss Expansion Valve High Temperature Safety Control Receiver Insulation Panel Bottom Insulation Panel Top Divider Insulation Clip Page 9 CCM Series Service Parts Remote Page 10 CCM Series Service Parts Item No. CCM0830 5 1 1 620204688 2 620204612 3 620204614 4 620204476 5 620204603 6 620204534 7 620204535 8 620204606 9 620204474 10 620204882 11 620204924 12 620204480 13 620204475 14 620204612 15 620204614 16 620204856 17 620204526 18 620204527 19 620204623 20 620204926 21 620204927 22 620204458 Model Number CCM0830 2 1 CCM1030 5 1 620204686 620204685 620204612 620204612 620204614 620204614 620204476 620204476 620204603 620204603 620204534 620204534 620204535 620204535 620204606 620204606 620204474 620204474 620204882 620204882 620204924 620204924 620204480 620204480 620204475 620204475 620204612 620204612 620204614 620204614 620204856 620204856 620204526 620204526 620204527 620204527 620204623 620204623 620204926 620204926 620204927 620204927 620204458 620204458 Remote CCM1030 2 1 620204815 620204612 620204614 620204476 620204603 620204534 620204535 620204606 620204474 620204882 620204924 620204480 620204475 620204612 620204614 620204856 620204526 620204527 620204623 620204926 620204927 620204458 Description Compressor Hot Gas Valve Body Hot Gas Valve Coil Low Pressure Control Filter Drier Service Valve Core Service Valve Cap Receiver High Pressure Control Expansion Valve Insulation Danfoss Expansion Valve High Temperature Safety Control Pump Down Control Liquid Line Solenoid Body Liquid Line Solenoid Coil Valve-Shut Off Remote Fitting 3/8 Male Remote Fitting 1/2 Male Check Valve Insulation Panel Bottom Insulation Panel Top Divider Insulation Clip Page 11 CCM Series Service Parts Control Box 14 Page 12 CCM Series Service Parts Item No. CCM0830 5 1 1 620204553 2 620204557 3 620204548 4 620204551 5 620204559 6 620204545 7 See Below 8 See Below 9 See Below 10 620204555 11 620204476 12 620204310 13 620204552 N/A 14 Model Number CCM0830 2 1 CCM1030 5 1 620204553 620204553 620204557 620204557 620204548 620204548 620204551 620204551 620204559 620204559 620204545 620204545 See Below See Below See Below See Below See Below See Below 620204555 620204555 620204476 620204476 620204310 620204310 620204552 620204552 N/A N/A Control Box CCM1030 2 1 620204553 620204557 620204548 620204551 620204559 620204545 See Below See Below See Below 620204555 620204476 620204310 620204552 N/A Description Purge Switch ON-OFF-WASH Switch Relay Socket Relay Water Pump Cord Contactor Compressor Start Relay Start Capacitor Run Capacitor Timer Low Pressure Timer Initiate Curtain Switch Assembly Curtain Switch Bin Thermostat Compressor Components Model Number CCM0830 2 A & W 620204686 620204649 620204672 620204678 Compressor Start Capacitor Run Capacitor Relay CCM0830 2 R AND CCM1030 2 A & W 620204687 620204649 620204672 620204678 Compressor Start Capacitor Run Capacitor Relay CCM0830 5 A W & R 620204688 620204654 620204672 620204675 Compressor Start Capacitor Run Capacitor Relay CCM1030 2 R 620204815 620204651 620204670 620204676 Compressor Start Capacitor Run Capacitor Relay CCM1030 5 A W & R 620204685 620204649 620204670 620204678 Compressor Start Capacitor Run Capacitor Relay A = Air Cooled W= Water Cooled R= Remote Page 13 CCM Series Service Parts Harvest Assist Assembly Page 14 CCM Series Service Parts Item No. CCM0830 5 1 1 620204366 2 620204631 3 620204569 4 620204483 5 620204481 6 620204439 7 620204484 8 620204424 9 620204427 10 620204451 11 620204516 12 620204556 13 620204407 14 620204434 15 620204452 620204312 Model Number CCM0830 2 1 CCM1030 5 1 620204366 620204366 620204631 620204631 620204569 620204569 620204483 620204483 620204481 620204481 620204439 620204439 620204484 620204484 620204424 620204424 620204427 620204427 620204451 620204451 620204516 620204516 620204556 620204556 620204407 620204407 620204434 620204434 620204452 620204452 620204312 620204312 CCM1030 2 1 620204366 620204631 620204569 620204483 620204481 620204439 620204484 620204424 620204427 620204451 620204516 620204556 620204407 620204434 620204452 620204312 Description Bracket, Probe Motor Gear Motor Clutch Assembly 180 Degree Snap Bushing Snap Bushing #6-32 x 1/2 Fillister Head Screw Connecting Rod Probe, Single Length Plain Flat Washer Shoulder Screw Spacer, Cam Switch Cam Switch Insulator, Switch Pan Head Machine Screw Speed Nut Plate Complete Assembly Page 15 CCM Series Service Parts Remote Condenser Page 16 CCM Series Service Parts Item 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 RC Condenser CCM0530R CCM0630R CCM0830R 1 CCM1030R 1 CCM1448R1 CCM1530R1 CCM1848R1 CCM2148R1 RC05001 620204581 620204369 620204436 620204580 620204647 620204425 620204426 620204448 620204436 620204371 620204373 620204374 620204375 N/A 620204373 620204377 602204372 620204370 620204379 620204378 620204376 620204625 620204600 620204626 620204527 620204526 620204627 RC06002 620204581 620204369 620204436 620204580 620204646 620204425 620204426 620204448 620204436 620204371 620204373 620204374 620204375 N/A 620204373 620204377 602204372 620204370 620204379 620204378 620204376 620204625 620204600 620204626 620204527 620204526 620204627 RC08002 620204581 620204369 620204436 620204580 620204646 620204425 620204426 620204448 620204436 620204371 620204373 620204374 620204375 N/A 620204373 N/A 602204372 620204370 620204379 620204378 620204376 620204625 620204600 620204626 620204527 620204526 620204627 RC14002C 620204581 620204369 620204436 620204580 620204646 620204425 620204426 620204448 620204436 620204371 620204373 620204374 620204375 N/A 620204373 N/A 602204372 620204370 620204379 620204378 620204376 620204625 620204837 620204626 620204527 620204526 620204627 RC21002C 620204843 620204838 620204436 620204844 620204846 620204425 620204426 620204448 620204436 620204371 620204840 620204374 620204841 N/A 620204840 N/A 620204839 620204370 620204842 620204378 620204376 620204625 620204845 620204626 620204527 620204526 620204627 Page 17 Description Fan Guard Top Panel ¼-20 x 1/2 Screw Fan Blade Fan Motor ¼-20 x ¾ Cap Screw Flat Washer Flanged Lock Nut ¼-20 x 1/2 Screw Rear Panel Brace Leg Leg Brace T-Nut-Shipping Only Brace Cover Panel Center Panel Front Panel Motor Brace Motor Brace Support Junction Box Cover Mixing Valve Condenser Filter 1/2 Coupling 3/8 Coupling Filter
