Download SONY CPD-15SF22015-05-09 02:073.2 MB - Wiki Karat

page
1
page
2
page
3
page
4
page
5
page
6
page
7
page
8
page
9
page
10
page
11
page
12
page
13
page
14
page
15
page
16
page
17
page
18
page
19
page
20
page
21
page
22
page
23
page
24
page
25
page
26
page
27
Transcript 
CPD-15SF2I15SF2T
POWER
SAVING
FUNCTION
This monitor
meets the power saving guidelines
set by the
EPA Energy
Star Program
as well as the more stringent
TC092 guidelines
(NUTEK).
It is capable
of reduced
power
consumption
when used with a computer
equipped
with
Display
Power Management
Signaling(DPMS).
By sensing
the absence
of the sync signal coming
from the computer,
it will reduce the power consumption
as follows:
Power
consumption
State
CAUTION: The Power Saving function
will automatically
put the monitor into Active-off state if the power
switch is turned on without any video signal
input.Once
the horizontal
and vertical syncs
are sensed, the monitor will automatically
return to its Normal operation state.
Required
resumption time
<9Power indicator
POWER SAVING
indicator
green on
off
1
Normal operation
100%
2
Suspend
(1st step of power saving)
approx. 10%
approx. 3 sec.
green on
orange on
3
Active-off
(2nd step of power saving)
approx. 7%
approx. 10 sec.
off
orange on
TIMING
SPECIFICATION
Mode
Resolution(H x V)
Dot Clock(MHz)
1
3
2
4
5
1024 x 768
78.750
6
1280 x 1024
110.000
640 x 480
25.175
800 x 600
49.500
832 x 624
57.283
1024 x 768
65.000
31.469
31.778
0.636
3.813
1.907
6.356
25.422
46.875
21.333
0.323
1.616
3.232
5.172
16.162
49.725
20.111
0.559
1.117
3.910
5.586
14.524
48.363
20.677
0.369
2.092
2.462
4.923
15.754
60.024
16.660
0.203
1.219
2.235
3.657
13.003
63.953
15.636
0.727
1.018
2.255
4.000
11.636
59.940
525
10
2
33
45
480
75.000
625
1
3
21
25
600
74.550
667
1
3
39
43
624
60.004
806
3
6
29
38
768
75.030
800
1
3
28
32
768
59.938
1067
1
5
37
43
1024
External
(-)
(-)
Non-Interlace
External
(+)
(+)
Non-Interlace
External
(-)
(-)
Non-Interlace
External
(-)
(-)
Non-Interlace
External
(+)
(+)
Non-Interlace
External
(-)
(-)
Non-Interlace
Holizontal
Hor. freq. (kHz)
H-total
H-Front porch
H-Sync width
H-Back porch
H-blanking
H-Active
(~sec)
Vertical
Ver.freq. (Hz)
V-total
V-Front porch
V-Sync. width
V-Back porch
V-blanking
V-Active
(Lines)
Sync.
H-Polarity
V-Polarity
Scanning mode
-2-
CPD-15SF2/15SF2T
SAFETY
CHECK-OUT
(US Model
After correcting the original service problem, perform the
following safety checks before releasing the set to the customer:
1.
Check the area of your repair for unsoldered or p<?orly-soldered connections. Check the entire board surface for solder
splashes and bridges.
2.
Check the interboard wiring to ensure that no wires are
3.
"pinched" or contact high-wattage resistors.
Check that all control knobs, shields, covers, ground straps,
4.
and mounting hardware have been replaced. Be absolutely
certain that you have replaced all the insulators.
Look for unauthorized replacement parts, particularly transistors, that were installed during a previous repair. Point
them out to the customer and recommend their replacement.
5.
Look for parts which, though functioning, show obvious
signs of deterioration. Point them out to the customer and
recommend their replacement.
6.
7.
8.
Check the line cords for cracks and abrasion. Recommend
the replacement of any such line cord to the customer.
Check the B+ and HV to see if they are 5pecified values.
Make sure your instruments are accurate; be suspicious of
your HV meter if sets always have low HV.
Check the antenna terminals, metal trim, "metallized"
knobs, screws, and all other exposed metal parts for AC
Leakage. Check leakage as described below.
To Exposed
Metal
Parts on Set
AC
Voltmeter
(0.75 V)
1.5 kD.
0.15/-1F
-=-
LEAKAGE
TEST
The AC leakage from any exposed metal part to earth ground
and from all exposed metal parts to any exposed metal part having a
return to chassis, must not exceed 0.5 mA (500 microampers).
Leakage current can be measured by anyone of three methods.
1.
2.
3.
A commercial leakage tester, such as the Simpson 229 or
RCA WT-540A. Follow the manufacturers' instructions to
use these instruments.
A battery-operated AC milliammeter. The Data Precision
245 digital multimeter is suitable for this job.
Measuring the voltage drop across a resistor by means of a
YOM or battery-operated AC voltmeter. The "limit" indication is 0.75 V, so analog meters must have an accurate lowvoltage scale. The Simpson 250 and Sanwa SH-63Trd are
examples of a passive VOMs that are suitable. Nearly all
battery operated digital multimeters that have a 2 V AC
range are suitable. (See Fig. A)
WARNING!!
NEVER TURN ON THE POWER IN A CONDITION IN
WHICH THE DEGAUSS COIL HAS BEEN REMOVED.
SAFETY-RELATED COMPONENT WARNING!!
COMPONENTS IDENTIFIED BY SHADING AND MARK &.
ON THE SCHEMATIC DIAGRAMS, EXPLODED VIEWS
AND IN THE PARTS LIST ARE CRITICAL FOR SAFE
OPERATION. REPLACE THESE COMPONENTS WITH
SONY PARTS WHOSE PART NUMBERS APPEAR AS
SHOWN IN THIS MANUAL OR IN SUPPLEMENTS
PUBLISHED BY SONY. CIRCUIT ADJUSTMENTS THAT
ARE CRITICALFOR SAFE OPERATION ARE IDENTIFIED
IN THIS MANUAL. FOLLOW THESE PROCEDURES
WHENEVER CRITICAL COMPONENTS ARE REPLACED
OR IMPROPER OPERATION IS SUSPECTED.
A VERTISSEMENT!!
NE JAMAIS METTRE SOUS TENSION QUAND LA
BOBINE DE DEMAGNETISATION
EST EN LEVEE.
ATTENTION AUX COMPOSANTS RELATIFS A LA
SECURITE!!
LES COMPOSANTS IDENTIFIES PAR UNE TRAME ET
PAR UNE MARQUE &. SUR LES SCHEMAS DE
PRINCIPE, LES VUES EXPLOSEES ET LES LlSTES DE
PIECES SONT D'UNE IMPORTANCE CRITIQUEPOUR LA
Earth Ground
Fig. A. Using an AC voltmeter
only)
to check AC leakage.
SECURITE DU FONCTIONNEMENT. NE LES REMPLACERQUE PAR DES COMPOSANTSSONY DONTLE
NUMERODE PIECEEST INDIQUEDANS LE PRESENT
MANUELOU DANS DES SUPPLEMENTSPUBLIESPAR
SONY. LES REGLAGES DE CIRCUITDONT L'IMPORTANCE EST CRITIQUE POUR LA SECURITE DU
FONCTIONNEMENT SONT IDENTIFIES DANS LE
PRESENTMANUEL.SUIVRECES PROCEDURESLORS
DE CHAQUE REMPLACEMENT DE COMPOSANTS
CRITIQUES, OU LORSQU'UN MAUVAIS FONCTIONNEMENT EST SUSPECTE.
-3-
CPD-15SF2/15SF2T
TABLE
Section
1.
OF CONTENTS
Title
GENERAL
Pa~e
...................................................................
2. DISASSEMBLY
2-1. Cabinet Removal
2-2.
2-3.
2-4.
7
7
7
8
Service Position
D Board Removal
Picture Tube Removal
3. SAFETY
RELATED
ADJUSTMENT
4. ADJUSTMENTS
5.
5
9
10
DIAGRAMS
5-1.
Block Diagram
(with Frame Schematic Diagram)
13
5-2.
5-3.
(1)
(2)
Circuit Boards Location
Schematic Diagrams and Printed Wiring Boards...
Schematic Diagram of D Board
Schematic Diagram of A Board
16
16
17
23
5-4.
Semiconductors
26
6. EXPLODED
VIEWS
6-1. Chassis
6-2. Packing Materials
7. ELECTRICAL
27
28
PARTS
-4-
LIST
29
..s
a!
~
-a~
~
0::
~~
110"
t.5
~...
:>
Iii;t
.§ '
~
~ ~
8~
o~~
z
0
i= W
0 Wo
W
en ~+'I-
0
~
III
...
~o
.
~ f
IlllIIiii
,g,g:l
~EIi
.!! :I
E
't:c
III III III
0. CI.c
!111III 0..5
! ~ ::I
1111- c
.c
.'-oiiilll
III :I
...
~
~0\
.-Ine
::)
~
U
..
~
,,~~
~~
)j
""+
\1)
~I'
GI!
::::I
l'IS
~
g,,,Q
.5
000
""
Q)
.:11 -;;
~
.;
en
Ie,
III
m
.§, 's.~ ~
i ~ ~~
~ t'-.2..
. ~~ .-;:~
o~
"'"
~m11~';;j
~~E2fJ
.: C /I) r:l......
F~
i
~
f?:
~~
I0
~
'
0 Q.I
I- I
U
t~
J~
l.1
. .. .
ID
Q.I
8
1>
~]
I!
...~=
;~'I
~...
UI<
..I
I ca!
Q.I
r:l.
!~1
.oj
[vI
s:a..
~
:a
0
§ ~ ~ ffi]
I~!
I~!
iD.:
.5~]
I.GI!
,c
IIJ b1 0
~ ..
:r:-5
~
t~ 5
.J!s
Ii!
"="i
"'
.~ .E.E
. .
l!
~.t
~~
~lt
~~
:
u""
1~1
<I""
:~:
I(
F:~
a:
~-00
~
f-e
z
~
~
0
u
::r:
s
8
..
Ii;
N
1.0
~
~t;;
+
~
I~
D
~
N
~
:g
;a
0
J:~
E-<.S ....
\I)
~
8
p..,
v
's..
1
~:: ..0C
U)~
ra
"'0
0
"'.....
11:1 1/).....
g~~ ~i~
Ii!
...~~ "
~]
"'
..6 8 §
+e.g.g
~J!
-:5
::!+.
~
~
-5\-1
ijj..
~~
..co..
~
~c
IV
0
-'
~&,
'-'~
~
0 (I'J
,..
BaBe
e.. ~
:r
0
't:)
g~
""'
:::I........
.
0
:;
CJ
~
..
I.
t
:z:.y.
81;0
-5
II:!
cu
~
0"
""
c'
~
t~!
11111 s
''''''
1.1
n:I
~
..i
:: C
Q.I 0
N
.g
be
"
~
r!
~ ..i:
~
~"E t~
!5.~ 9"
~
",,,g.
.t l!; ~]
~
8
J'j-5
..8m1>
~
ra
:t<B.E
~D
~
.9.9 ~~ @~
~:Q
;:.1;1.
+. &~
N
.a.
-g
.9
..6"'
Q, ;;;\-I
~
>,
~
~ ~~~
B
..c:
bO
'J::
.c
~
Ev
'5,.
'§
~
I
" '
;a~ 'in
~
.~
~ II)
~
~
~'~
13-;;i j!O
i:
Ii
cII
a.
'0
:.
c
0
u
:
~~,
CJ
co
0
~
c
~.2..g~6~
~-g>-.E>-i5
11
~
'O'i
-a'= ~.s~
~~~~~~
~~!nGE
...
.E
,t;' ..s
~
,i:j
s
GI!
,c'
..
0
Qj
U
~t
9"
i
~'
-"
i
:a
Q
~ g~
22
~~
~ .c
~~
N
"
!~
Q
~t
r\
.. '- lJ
a e;.../
n
....
.9.8
Q.I
.s
',c
0
B*QI
""~
:::1"0
> ~
~~
6..
D
BaBe
ie
.~..s
11)::
:I
13
.2.~
f~
..stJ
::I bO
!5.s
.,d
Q.I
~
~ ft
-,,0
o::~
~
""
:JI
-5
!a
:g':
'I(
L".
0;
c
z...
e
o~
j
'E
~
.~
...J"'C
~<C
ffi 100
I~
~
gj
0
~
Cl.
,...
::s
..0
()
i(.
.15.
ti:a':I'
"tS
e~;
m
j
's..
g
E
g.
f,UJ
,1;1,
~
E(J
1;;
CLI
gc
;~!
~]
E:,0:: YlcD
I:eft "",Z
f,LIt.LI
~.5! -~
ii~
u~
8
BaBe
8
E
GI
f,!
.g
~
tGl
. . .
e
....
..E
DO
or:;
::s
~:I
,t; , .s
g)
ii:~
I, §
o.
.~~ '~g~
..s-5 ~ .~~
d .~]~
.~:::::
,,~ e s ~
"';t"
;g.~.£g~
ag~~.~.2..
~~~~]~
In
+'
L!
!.e
ta
k
£~ ~
~
s8 oS E
Ea! "2 ~
E ~ fj...
g§ ~~]
LO
II)
Q.I
£
N
..
~
::s
~i
0 :
u""
::
C
QJ 0
F:~
QJ;:
.s~
.E~
;::
II)
~
III
,GI
,'0
iO
~'.,
~.6
~.E
.e-E
~.:g
;GI
;111 ..1!"
E~
'..
£,SID!
N
N
N
N
>U::
'3~
s:::::
ocu=
:1i
N
[
~:r:u.. f'I')
c-
.5!~
]'x
N
:r:
~0\
..0
-.:t'
N
:5
to..
(f')
I.t)
X
6
.....
Z
r-..
a\
is
0
~~~0
"I:t' \0
X
~~X~0 aa
~0::- is co
~
",Sg.6~§.!oi
E-o..oulJ..l-JuP-.
A.
"EO
u ..:
f,.Q ~'0
ns::
~~:r: :r: :r: :r:
~~I.t)lQ
co
~.~
.g
EP'"~ 's
'eca, ~~.~ g;
13'J:
a.2
..' pus. qs-:cns
:: ~8..~~~ ~.E
""-"'~_....
'!
!S.o.!!,~P..B
~a N
N
..:
2.d ~
g ~ ~ ;j I!!
~
.
N
N
:r:
!J e 8
v '8
~ §] §
~ffi
.! £0 . 5.~ ~
> g~11 1
=
8~;;.g2§g'Oo
::s..1\-;UU::'.Cu~"'C
~~~ :5 q iU 2 e
;
I'
]~~§
'-1\-" t;<""g-s.s
:E
I.t) 0
t--. \0
N
~N
:1i :5
0
d
~\0
0
co
§
X
co
~a
f'I')
~I.t)
('I')
,§]~8§~~~3
':f t>o~S
Q.I
~ 0'"0
!t" .~
~.~;.~
~~~e
l)
e(/) Q.I
X
X
N
C()
.~
~ .s~§
,ra
.....S:::::
IU CLI
t]~]
~t'II) "'81rl1l)
~
f:) ,
'O~
N
> > ::g~
~P-1
"::E
>.
u
BI~~
~s.e~
::E;t ~"
..6i!:gt
i:t
e
..:
" (/)
~..:
u
:Ev
'i.1 ..:5
~ ~
0 ~~
..=;;;
r:l.
I/:)
g
'E-5~
.~
...c:
~ Iii ~..s ~
61Cl. ;:::;':::::2
~1Sfo,N
\0
~
0
.~ ...
-=
.ga-E.~
1: ftS...
~...;::1.1;
~ ~~
&Sg,~
~
z
OJ ...
~
~"C,g~~"O'O~U)
ig~e3~:a"S'9]
o~-50]
~';!
'!..r::~~~~m~~
] .~
.~ r~ ~
"u~""C"'CIoran:l.-
~
U
.~
§
-8 ~.!!i ~ .b 13 -.'!J
c 1I.I,.c !'ISra Q.I.t: rn '.C
E'3].~.'!Jii1.e~5
~ ~ 2(3ffj~~] ~
u'g'§»>;!;~U
.I!:r::r:;:::R ;;'::0
E
6 Ii !
:o:::siii
~.5di
1111):E
c :I C
o~o
~:1-:1
:n~
...
CI'"III
C;;c'"
"'C
GI
.-c .'S .5 ~
ft1
~:DCI
.0..5 +'
'So'S
~
~ ~
0._0.
°EO
~~~
~......
'"
0\
e
=GI
"
iJ!
cu;EU
-5,,~
-::E1ii
-5
r.it:
cubOta
" .= P..;2
:; ,2~~~
-~~'~-""
,g;SEN.£O
.g
!..g
.g ~ ~
Sp.,IUI.t)U'>
a ~8.~::;:
~;::
8 e e-~
~
eg"E g~g.gM~]
;t
~
.
cu>.8cu-""""fi.c1'Cl1II
~s:::::te~~gt~~]
Q.I
cu'''' ~ r:: IU >.!
-a."g
8.:8-5 ~~jS'B
.g
:::
'i
~
j
.K}
">
Q.I
£
-5
£.9
.,e"'O
i;j
... s:::::
~ £5'"~
~
~
cc-tnUOBOt::J....
.;;; 6 .s ~..:
;t i!J.E
~1/1; '2 gp~ ';!0 iig-Ilo
0 8.!!
> S ==' ~ ~
.~ 0 ." L'
-5 e e '"tIS$-S !!j..t:"'C I'IS:~
~.~e !.B"i:S];5:
~
.~ ~~ 0 '§ -g ~ 6 .;j -d .~
...~,-.:11 S """.~~ ~2
a oE:£ lII'e.] 0'\:1'= Po.
;i1]:H ~ g.~ ~ ~ [.g
~«I
ii
...
~
~.£i
0 0
a!..s
.
t)~
g
-5"
.~ Iii
:5
~~
~ '>
~
I/:)
9 .~
0
'8
0 S
S ..
..-5
-52 .
-5"'d~g
~~
~
a.
.9
~OJ)
s:::
"tS
8...8.
~-g
:5 '~.s :a B
g
...
IV
.. ;t
~bO,~
r;-:=] ~e>, 'a~ 5-5
c c :I
~1!
::J ....
I1!
a-2
8.£.Q
<LIn:I
..r:: v
t
e... ;
J0 Jt
0.
J ea8s
i
~1
~.:;;
0
N
a.
~
&;
-5-
=E
a
..:;
~::I
s""
8
8v
ra
In
Q.I
]811)
e
~]
C
8
.........
~Q.I
II)
'"
~~=
"tS
c~rei OJc
.e
~'"'
~';!
c
0
E
::I
f-<
-5
u
~i! ;;
~;.co..
::E
~O ~~~""
tIS
6
~>."':
ij R 'O.g
c C
C
......
g
>.
~,;;
~~Q,:';
a.
~II
:;;
00
'"
:!
S
.- 0>.
~;n
<o:t
,~..
III
D'
C
.E
i=
>..
!s'
~
S.
c~
'~<c
~,~,~"
{j g.O~iJ
S
J!!.8
\D ~6 '":;a
l!]::'€~
:c;::::
-ai
~.~
~
Z ~ ; ] ,~] !! iJ ]
SJj ~iJ.8.~Jj-E
D'
S !; !;..~"8 .~
C 2"p..a:""""
.-...
Sc
w
~C
EU'~~~]
~
LL.
0\
C
os:
fa
B~
.~ S'" ti S
~~~.2...e
0£;'2 ~-g~]
'§
~_:1I>,
0
'::':; 2..5] ]l!
~ f] !a~ ~ ~
2~.t~~
~-[
g
iU',8e '~
c
'"...
'S:~ ~~ s e "~ eLl
'0
"ii.8-~]:1"8 j9
oW
!!
;:
~ <: ~
a.
~~
~ ]-~
ell
e
.:: :::
>-.9
~"O
,-o"bO~lii-oS
:=:
0
j ~ ~ 8 .~] ~ ~
-g
$: ~-s ~
~
~
of:
~
~
~
@
CIJ'
I:L
E:
CIJ
..;
0
~
'0
~
\I'
~
0:
at
aIt)
00:
°:; ~ ~
~
,,~~
~C:O
~
99
'8,~
iJ-
~~
=.
CIJ:
VI;,(
~w
o:...J
o~
...J-
~. ~~
]~
oi!!
~~
C
.-'
CIJ!
~
0
alII
0
lt)~
w
a..
C'CS
8.
CIJ'
0
alII
CI)
m
w
a:
~
c
0
'
>,
~
~~
00
U\J
~.8
~
~~
~~z8.j&§
.
~
t.
~
~°
S!-3
~] §
~!S
....
0..0
=
tJ
~::J.c
CU"'"
g~::E
\-'
l!::E.2/
~~~....
Ons
&! r.LIen
es~]
CLI' Q.I 0
~N
'
1!
...
~~]~
~~~~
i!9'
','
~:c
1.5
t= 1
t
~~~~c:O
. ~tJ
.....
~
31
-5 B.S;
p.. ~ ~
0
III'
~.ff]t'IS~..a
~ ~
1~j
~I!!
i3
Po.
Po.
.~
~.s ~"tS
:a >.
:c
~~=.
~14J
~CJ
I
,~~
Q
1i:1
ooD
!S
~~.~
Po.
.s
.... Q.I
~iU
~@
m
g . "i!
>,
~5
~I'
]
::E
it
<1'
Q.I
:a
.8
.9
Il..
.
t
oS 8
II) !)
.t~
'0
~p.. f,CIJ
IClJj
~8~~
'"0
u)
.5
~,S ...
II
~~l3.g
'.,
~~~~Iii.~
~:f~
N
I
-=
N:
in
:I'
w!ll
N
:c
='
C'"
8
.-~A.i
=Cf.I
~~~iGlj Q.I
J:,
",,:
cCIJ 'm
e
]
:laj
ra
,,2(.
~o.
;:sra
ra > .00
~~C
~'~ ~?
Iii..
.-.
....'
,,1/1,
.~
:,:1:
."c:c:
lI'J..J1t
.§.. i!!
.a..~
Cf.I
.....tJ)
tl)t
"1j
~ftS""
Q.I
5.
~,S; ...
~c::
.s~
Q.I
:s
~~,'"~<LI
11
t'IS
:§o
(jj
}1
!
,5
wi:
GI: .2
II(
~~8
" ~ ... ,£!
~ i!
~,,:c~t~
e i
-at
.s
CLI
:t'I
E
....
1/1
:I
......
9'~~
8~~~
::t o~o
l!~9~
~
]1i~~:;a
,£! .e ..
-c::(.Q"'Ij
S
".5
6,gcu~'i
c::
~~"
~!S
&.
n
.8.n ~ .2-
~(:1
,,0
t'IS
- ~ I ~~
~ J!J
'"
~ . ~:~
CD
"'0
~~:laj
{j'f'S~S
~~=>'~~
~i
~
tJ
h~B ~.~,
§"8
'
It;j
~
:;a
~~ ~
§i
~
0..'"'
2(. "C
.2/. ~~
S
L
1/1
....
~
0
°
g
:;a
u
1::
Q '~.5
!S ~l!
a
~~ ,g]~
~~ 8..8
~"oS
>,°
~Q.,
t
R
!
-~.
f~
Q.1
as"'"
.a
.E}J
',
...
en
!II
::;
>
g
~~"'C,...
~51
~~o
,"",
~III .§] oS'"
(:1
1/)1:.
1:1
!!
bO
~.... ;a 'in enQ)
,,,
:C:C.
i~ ;g~
~].t
Iii
]
.....:J
.s
~~ i~:r.
.~ ~
-ti,~ ='U~
.5
:E.9
~~~"
'*
~ ~ Bo8e .E~ =~~~
is,o
.t
aJ
'~
Q.1
:0
~°i:
C"
'§
@j
l
cf)
N
H~e
.gC7\:g
>a:
~~>. 'i!l
,u
~~§ ._,
A.
jGl
~H
l
~
'0
&i~
]1
.9£
,J:
IV
~'O~
~~'"Oo"S:
ii~:g
~UI...
t :s-CI.I
zp..
'e"'~
° 0 "',;
<B
'8
11)0\
.E
~~'!c
-~
c::
a
§~
t '8
Po.
Q
t'IS
,~
'"0
~g
+~
e~.8 Bo8e
.s
: :
cn+.
I~
-
f
,~~
~R
~~~Q
~.s~O
OOC::JC'\
.d.
,
l!
UtaUCIS
..a
~
E
:~
]
t'IS
!!
~cu
.~
e
en
G!"G!"
f:Rt;ie~
Lt')
c::
'0
.-~o
CI.I
Q.1
:e
-s-~~~&:
><
e..
~§ Q.,°
~Q.,-
8
}I
~
~~rt) &:.:;
10-
~
>.
.5
,g
e~D.,IIJI
..
~t
~
::::I
cu
co
,~
-=
>1
I
....
~
0
iii
s:::
.9
os
~~~,~
e
':'
5
l l
~~}~]
~iJ ~ iJ!
~~~~i5~~ ,a p.. 0§
.. « ~ ~...
.~
~~0
5
0
~-s-8 "t1o
~"-'~6JZ
5o...s S!.~
z
§
(:1 &:
PB
"
~~fo
co
c1i]
~
i~g,~
~
(/)
S
:I ~ ~~ &~
...
N :::I >.~....
0
~~,~0
~
g
s:::
~l:Jo
1)
31
'0 ar~ S ~
8 ~ ~ «i ~
:c..~}Jp...g§
~~:9:P]
;§ ~ C'CS
[8 QQ',;:! ca ell > QJ'J:!
cuo~ebO.5a>. > !!
,S S :1 S::::~'OI::
S v
~bocu,~
8 $8tl1
~ 0d, t'tS C 0
C
:s ;!:s
.
§
bO~":~,~...
'B'£..q~~ ti
'~~i!J''''2§,''
<; «
,e~
l'!'i:§~Iii'o;~
..2,9
£::...6
1ii~~"S~8.
~.= 6..8CI.I,.9'~
C ....
~ ~ '::; !! gj,~"
IS "'C
'>
8.S~iii!!"oS!!oS1j
~'eEoS~g.
"i!~ODO3:~
'0 ;:I Iii~E~~...
-=
~ ",~ 0 .
1j]
1jj ]-r:;;a!!)
.i:!.. ~ II) Q.I
~
~J:~
N
]
~~::EI!!
~g
ai
:~~
-
'"
°
~i,~~"
i ~.i 8
~.E ...
:1'U 8
~
~
be
..8
i
f!!
r.a:
rf!
..
~.
~-§
ii:tj
~c::§
~.5
tJ
.~~
~~c:O -g+
...e
Bo8e
'f"
"oSIII
d~~>
{.I..p..
"l'!
oS;;:;
..c .§.s
~:e .2.t
"'Ij.......
~,§
C1.I"'O :I,
~.
~~.9.9 §,~ 8
~oS
..c U'.I'I)'
...
-5i
Q.,u
..".C
0
~!S.8~
, e':1
~tJ ;;:;]
\"!Sl!
.t ~~i3
:~
.9.9
~":1
0.0
~t
i!\""i!
Q.IQ.I;:S
N
-6-
F'cl
,o:
'"
:;a
~"J!
..E
'"
or
,:111:;
S!
>
~~~co
0
::;
to
'"
r~~[fl
@
~~:!/
,:1\
I
~"'0~.
~; ,s
~iA.i
,,0 ~CIS
t CIJ;
~!S
.5.
]
[~i
i,1
of!
.,D'
'C.
~;c:O
res
"tJ
;:i,i
!
:"1
«IQ.I&.
.
~o
..11ft ~oS'"(:1~'.,
r.:Ii .a..~~'.....1
"0
11(:
p..~
...
~~~~,S
CD
CPD-15SF2/15SF2T
SECTION
2
DISASSEMBL
2-1.
CABINET
REMOVAL
CD Two
2-2.
Y
SERVICE
claws
A board
"-
t
~~
.....
......
....
.....
2-3.
D BOARD
REMOVAL
-7-
POSITION
CPD-15SF2/15SF2T
2-4.
PICTURE
TUBE
REMOVAL
<V Two screws
:~=~ i
,,'WW\""
S
(§)Neck
assY
I
G) Stand
(D
Y
~iY
boa/"
. REMOVAL
NOTE:
OF ANODE-CAP
Short circuit the anode
removing
the anode.
. REMOVING
J
of the picture
tube
and the anode
cap to the metal
chassis,
CRT
shield
or carbon
painted
after
PROCEDURES
~@,---,j
@-@
Anode
<D Turn up one side of the rubber cap in
the direction indicated by the arrow @.
. HOW
on the CRT,
TO HANDLE
@
Using a thumb pull up the rubber cap
firmly in the direction indicated by the
arrow @.
AN ANODE-CAP
<D Don't hurt the surface of anode-caps with shartp shaped material!
@ Don't press the rubber hardly not to hurt inside of anode-caps I
A material fitting called as shatter-hook
terminal is built in the
rubber.
@ Don't turn the foot of rubber over hardlyl
The shatter-hook
terminal will stick out or hurt the rubber.
-8-
Button
@ When one side of the rubber cap is
separated
from the anode button, the
anode-cap
can be removed by turning
up the rubber cap and pulling up it in the
direction of the arrow @.
~
CPD-15SF2I15SF2T
SECTION 3
SAFETY RELATED ADJUSTMENT
When replacing or repairing the shown below table, the
following operational checks must be performed as a
safety precaution against X-rays emissions from the unit.
Part Replaced (8)
1:::---1
RV470
------HV Regulator
Circuit
IC501, FBT (T501),
R457, R475, R487,
R508, R509, R512,
RV470,C509, C526,
C541, C542, C580,
C585
HV Hold-Down
Circuit
D board
IC500, IC501, D407,
D515, R472, R492,
R494, R496, R577,
C402, C403, C404,
FBT (T50l)
. Mounted D board
Beam Current
Protector Circuit
D board
IC500, IC501, D596,
D597, R450, R459,
R460, R498, R970
C528, C549, C938
. Mounted D board
*
.
.
.
Part Replaced (~)
D board
c) Beam Protector Check-1 (Software logic)
1) Using an external DC power supply, apply the voltage 7.00:!: 0.05 VDC between pin @ofFBT(T501)
and GND, and confirm that the voltage of both ends
C938 is with in the voltage range shown below.
Standard voltage: Less than 3.26 V DC
Check Condition
Input voltage: 120:!: 2 V DC
Input signal: Any pattern (fH =63.9 kHz)
Controls
: CONT and BRT -+ Minimum
: Screen VR (G2) -+ Cutoff
d) Beam Protector
Check-2 (Hardware
logic)
I) Applying specified external DC voltage 5.00 V DC
at between C938 (Side of anode) and GND.
2) Confirm that the beam current protector circuit is to
be activated when to make short between pin @ of
FBT (T501) and GND.
e) +B MAX Check
1) Input white cross hatch (fH = 63.9 kHz) signal.
2) Minimum CONT and BRT controls.
3) Input voltage: 120:!: 2 V AC
ConfIrm one minute later turning on the power.
a) HV Regulator Check
1) Input white cross hatch signal. (fH =63.9 kHz)
2) Minimum CONT and BRT controls.
3) Cut off Screen VR (G2).
4) Input voltage: 120:!: 2 VAC
5) Confirm that the voltage is within the voltage range
shown below.
Standard voltage: Less than 25.5 KV
b) HV Hold-Down Check
l) Using an external DC Power supply, apply the voltage shown below between cathode of D407 and
GND, and confirm that the HV Hold~Down circuit
works. (TV Raster disappears)
Standard voltage: 31.6 :!:0.05 V DC
Check Condition
Input voltage: no:!: 2 V AC
Input signal: Any pattern (fH = 63.9 kHz)
Controls
: CONT and BRT -+ Minimum
.
.
.
: Screen VR (G2) -+ Cutoff
-9-
Note: Use NF power supply or make sure that distortion factor is 3% or less.
4) Confirm that the voltage is within the voltage range
shown below.
Standard voltage:
14O:!:2 V
CPD-15SF2/15SF2T
SECTION
4
ADJUSTMENTS
Connect the communication
then follow the instruction.
cable of the computer to the connector located on the D board on the monitor.
D
<D 1-690-391-21
IBM AT Computer
To BUS CONNECTOR
as a Jig
"The parts above ( <D
-@
4 Pin
4 Pin
mini Din
(BPin)
D-sub
(9 Pin [female))
.
) are necessary
1. Receive the picture with maximum frequency. (Dot signal)
2. Adjust "BRT" to "255", "H.SlZE" to "-127".
3. Set the lever switch (S5OO)to the CRT neck side (position
"a"). Select the minimum point of right and left difference of
the raster at (S501). Then fine adjust H.CENT at switch
(S5OO).
Correction distance change-over: S500
~
a
neck side
0
c
t
a 2mm
Shiftingdistance b 4mm
CRT side
5mm
* Correction direction change-over:
SET
a
rear side
4 Pin
for DAS adjustment.
H.CENT Adjustment
(This should be performed before Convergence Adjustment.)
*
Run the service software and
S501
SET
front side
moving direction {~ ~f~t
-10-
.
1.
2.
3.
4.
Landing Rough Adjustment
Enter the full white signal.
Adjust the contrast to the maximum.
Make the screen monogreen.
Reverse the DY, and adjust coarsely the purity magnet so
that a green raster positions in the center of screen.
5. Moving the DY forward, adjust so that an entire screen becomes monogreen.
6. Adjust the tilt of DY, and fix lightly with a clamp.
.
1.
2.
3.
4.
Landing Fine Adjustment
Place the set in the Helmholtz coil.
Enter a green signal only.
Degauss the entire screen with hand-degausser.
Attach a wobbling coil to the specified position of CRT
neck.
5. Attach a landing adjuster sensor on the CRT.
6. Using a landing checker, adjust the DY position, purity, tilt
ofDY.
7. Clamp the DY screw.
Clamping torque: 22:1:2 kgcm (2.2 :I:0.2 N.m)
. Convergence Rough Adjustment
1. Enter the white crosshatch signal.
2. Adjust roughly the horizontal and vertical convergence at
four-pole magnet.
3. Adjust roughly HMC and VMC at six-pole magnet.
CPD-15SF2/15SF2T
.
Convergence Fine Adjustment
10. Adjust V.TILT with TLV VR.
Set DY four-pole magnet to mechani*
cal center
before adjustment.
This should be prime mode.
*
TLV movement
Setthe /
-fJ-
~
NECK
R
B
'-"""
Assy
I
6-pole Mg
R
B
Mechanical
Center
~
finger
11. Adjust Y.CLOTH with YCH VR.
P.S Mg
"""'1/'
YCH movement
x
B
R
1. Receive R.B. cross-hatch.
2. Adjust H.STAT and V.STAT at four-pole magnet.
12. Paint lock the four-, six-pole Mg.
XCV
< VR Adjustment on DY >
< 4 Pole Magnet>
@<:::?
<D
~<D
@
1
<D
@<C=?
~<D
@
+-R
&:.
YCH I'il
~
<D+@
B-+
it
+-R
~
]
A
< Zero Position NECK Ass'y >
<D+@
~R B
Purity
R -+~
~'E- B
~ )
~
@<:=;:::J
5.
6.
.
~+-G
~<D
Receive R.B. cross-hatch.
Adjust XBV at DY four-pole magnet.
.
@When~B
'
/
R
I
a
!
I 1..
~
(Qj~Less
I
~n
1) Open DY four-pole. (Do not move H.STAT)
2) Re-adjust V.STAT with four-pole at NECK Ass'y.
/
a
a < 2.5mm
b < 2.5mm
I
I
tOmm
@When '
~B
.-- ""-
------------
!
cQ;
~
Vertical and Horizontal Position and Size
Specification
I
I
XB V Correction
R
~
6-Pole Mg
DY XBV
G-+~
~<D
4-PoleMg
9
3. Receive White cross-hatch.
4. Adjust HMC and VMC at six-pole magnet.
< 6 Pole Magnet>
@<:=;:::J
.
TLV
B-+U
R-+
+-B
0
~
~
I
1
B
b
~
.
cQ --+ (Qj~Less
b
Convergence Specification
than
/f
10mm
1) Close DY four-pole. (Do not move H.STAT)
2) Re-adjust V.STAT with four-pole at NECK Ass'y.
A ~ O.30mm
B ~ O.35mm
7. Repeat the above procedure so that R.O.B. will be on X. Y axis.
8. Adjust H.TILT by swinging the DY neck right and left.
9. Adjust XCV with XCV core.
XCV movement
x:
-11 -
[OJ
CPD-15SF2I15SF2T
MEMO
,...............................
.....................................................................................................................................................................................................................
,
,........................
,.................................................................................................................................................................................
''''''''''''''''''''''''''''''''''''''''.''''''''''''''''''''""'"'''''''''''''.'''''''''''
.....................................................................................................................................................................................................................
"""""""""",.."""","""'''''''''''''''''''''.'........................................................................................................................................................
"..'."'."""'"''''''''''''''''''''''''''''''''''''''
,........
,......................................................................................................................................
,
,.................
,.................................................................................................................................
,
,.........................................................
,.................................................
.....................................................................................................................................................................................................................
'"''''''''''''''''''''''''''''
,.......................................
,
,.........................................................................................................................
",..,."""",,,,,,,,,,,,,,,,,,,,,,,,,,,.,,.,,,,,,,,.,,,,,.............................................................................................
""'"''''''''''''''''''''''''''''''''''''''''''''''''''''.............................
,
,
,.................................................................................
""",,,,"""""'"''''''''''''''''''''''''''''''''''''''............................................................................................
.....................................................................................................................................................................................................................
,.................................................................................................................................
".,."""""""",,,,,.,,..,,,,,,,,,,,,,,,,,,,,,,,,,,,...........................................................................................................................................................
.........................................................................................................................................................-............................................................
.....................................................................................................................................................................................................................
,,,,,,,,,,,,.,,,,,,,,,,,,,,,,,,,,,,,,,,,,,.,,,,.,,,,,,,,,,,
"
,,,,,,,,,,,,,,,,,,,,,,,,,,,,,,,.,,,,,,,,,,,,,,,,,,,,,,,,,,,,,
-12-
,...................................................
,..........................................................
SECTION
5
DIAG RAMS
5-1. BLOCK
DIAGRAM
(with
FRAME
SCHEMATIC
DIAGRAM)
CN30B
4P
1NHT
S-MICRO
GND
~10V
1
+12V
5
5DA
6
SCL
'"
3
SDA
SCl
2
1
+sv
DOC
le005
+5V
V.CLK
7
+140V
SIGNAL
CN307
9P
WHT
5--MICRO
HS IN
IN
I
~
I
b,
CN~05
11P
WHT
1 QV
2
+12v
3
GND
4
+5V
5
GND
6
NC
7
140V
B
NC
9
GND
10
l.pC'..A-~RJ::
,~_1
BPCLP
CONT
--EffiT--
8
12
7
6
5
VRTRC
H.RETRAC E
RESET
SDA
SCl
GND
--8 -2r-
.5 V-SYNC
COOT
[
17
16
15
f>\At..16
H1
J...t..?-
,,1'-
-- J1B~OSD-"
Q305
--,
23
RESET
SDA
SCL
PWJI5
PV.M4
9
--
G-CUT OFF
CONT
(2/4)
I C004
H-SYNC
14
-- '--
8
-
1.2kV
CN303
1P
GND
RVOO1
a-CUT OFF
CONT
le004 (3/4)
13
A
CN310
1P
GND
(VIDEO)
I
CN605
2P
WHT
. LARGE
,rir
.
I
L
,~II
,
I
o--1RELAV-DRIVEI
0601
TH601
.
PM.+-CONT
nv
~
126__H.51
.
-
'I~'
LJ
~
w,
I
1
!IJNr..1 ~
I
I
I
I
;
I
1'''0.
r
I; I' I'
V
VI
V
DY+
1
k ~:
I
I
'U"
CN51D
1P
-~
1
1Vttt:
If.?/ ~
~_.I"
-
L-j'
I~_,,-
"-
~
v
C~I]~
I
11
~1.,~~.IB&IIJ.'t._~f')A.Rt\-CLLn~4T1nN-
'
INI)? 9,'OloUT34
.I I,."~~G::-¥ORML.6
I I I
~II
I_Ll---L r-
.
~
!
I"
I
['
5501
-
D
[I:j;IJ
B",Ln..
J
I
IT'
j~J.
I~
1k;1I II~III
J9,!J I 1 I I
I
I; I'
I'
~-
.1
!DF...;.,r
'II
IN2HI
... ~---'
';~;:~
I
~1
I
I
:~~-
j'~0'~
I
I
I
:
I
-
I
.
j
t-u~
t'..a9DUCT I ON,
noted.
pF:
w-rr
!-
ru
J
.
I
.
.1
51 - - -11 T505
!
-
.
I I I I I
°1
. .I
(,
~~~~
~
_
_QI 1_ I_I
,','
.
_I
_I
-------
UIUll..icUCU. ,~t:Jc
I-'CI'::;tC~J
~~~--~-~~
~--~-~~~-~~~
-----
u_- ~..u-
.
"
All voltages
.--'
m~\1
rTSITn---
I
are in V.
are taken with a color-bar
\I~ri'!:liinnc::
..!..4Ul:;
FBT
Readings are taken with a 10 Mil digital multimeter.
Readings
A__\/nlt'=lno
--
.
,,,"1 IIT-U'bumr.'
IlnIA~~nthp.rwi~p.noted.1
nA
nntAri
+5V
D-GND-
signal input.
,'--
rlllA
tn
nnrm~1
nrnrtllr.tinn
"
"
rll
TXD
Eb
"!"-fUG~
I
A
: int~rnal component.
: panelj:lesian;ltion. al]d adjustment for repair.
Allvariable and adjustable resistors have characteristic curve B,
.~
I
-.
~---f\JJfI;
I
I:,'
II 'I
II
- ~'-'U~/(I--~-"
1
.
~ -1..-
'-""'-'--""-
n"'t:J"'t,
.
n"'t:JD,
~I:~~
'N,
n~",
I
JI
I ..1" T
IIV
0 boa'ra'
ICoOO,IC501, L14lJ(, r'-0515, R472,
~~~~'
IIUlu-uvR-f1nA
I..nAnL'
--.U\/...LJ
I
are in IlF unless
otherwise
~z
I
I.
I
I
RESET
HRTRC
I'11
1 4 I..
I
I 1
.
I
'
?F"I
'
-~IRE5ET
.
I 'IH/V"B<rK
I I
-
,
~
- ---,
-
:-""-'---""'
--
-
, I I ,
J
VRTRC.
6
119
riD",
1Ll
,-
.
°
(;;jC-SVNC'
ON GREEN
CL.AMP
CONTRA5 T
L~ I V-RETRACE
~~TH=SYNC
-
--i
~ BP-CLJIoMP
l~CONTRAST
,
.,.
..,.-;c
.'
8
7
--
V-UKV
..
I
- v-L:.-""v
ON,{Oa:;:J:~
I
~~
:1
I
~,-t~j;"
~r:::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::;:::::::::::::::::::::::::::::;:::::::;:-::;::::::::~::~::::~::~::::~::::~::::::::::::::::::::::::::::::::;:::;:;:::;~::::::::::::::::::::
:: Note: The components Identified by shading and mark
it are critical
for safety.
Replace
only with part
specified.
tolerances.
r
::~:~:::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::;:::::;::::::::::::::::::::::::::::::::::::::::;::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::::;::::::::::::::::::::::::::
:,:,
*
Circled
. _.
numbers
are waveform
B+bus.
B - bus.
:::::::::::::::::::::
Les composants
Identifies per un trame et une
marque it sont critiques pour la securlte. Ne les
rem placer que par une piece portant Ie numero
speclfle.
-16
: Can not be measured.
::::
05
Note:
I
'IC~~
~
number
-15 -
I1 I
H.S)"NC
.','
-14-
I~
RV470
_f",,- _1"~tj"1"'I
- h_""_'-"A -r"A
(8 )
IlIlF
II
I
13
_,",,""''''''r- -"
.
I
t
~.
I.
I
>----
nv,
1
13
...h.,.,.h-
I
I'
-- --
-
2P
S-MJ CRO
ROTATION +
4~
SYNC
I
I
l:
BP
J
u,",
I
Ir~~'~
5
I"
J...I_r:1
II s-?
I
I
1
r
1
I
I
I
~
RUIATH)N--
ROTATION
-13 -
I
50 WV or less are not indicated except for electrolytic.
II I I
I
~
--L
CiUJU:SUlltnu::t
.
---
o/
I
.."u" ."",,l&!:'ty".rR.')!;u.'i"l'I tluI.n;u;t.it\!1A.!o"'l.!.:i'bl!,- pe,~'~e. t.o.,p"rfnrm thE>
relatep adjustment.
-
I
""-'
'
I
-
I
k-,
~~T....
I"-----~
Part replaced
. All capacitors
~
~"TI~
-14J11~11:
:Q
I I
1.1111
necessary
~
I
~
"""'2P"''''
I
Note:
IC904
~'I ,
,
]C501
r:
'(
5W ITCH
rI
I
~n ._~
11
)
.
I
12 -10v
I,"",
POWER
D( DEFLECTION
~-..
-
references.
(1) Schematic
Diagram of D Board
.
CD
. D BOARD
VOLTAGE LIST
Pin No. Voltage [V]
Ref.
IC400
1
2
3
4
1.5
1.5
-10.7
1.5
IC500
1
2
3
7
0.2
5.2
4.2
3.6
IC501
1
2
4
5
6.1
9.2
6.8
6
8
9
10
11
12
13
14
15
16
17
18
5.6
7.2
4.7
5.7
6.1
6.1
6.1
6.3
6.1
7.9
2.6
4.7
Lilli
r
I
I
HV DET
~u
5.3
5.3
8.3
3.7
3.6
4.7
3.7
3.8
3.7
4.7
0
0
2.2
2
~
2.9
I
I
~
-----
I I
r-
.1.1
C-"
D-4
B-2
""v~
I
..t
-
60V
8
10.0 Vp-p (H)
9
IC400
IC500
IC501
IC502
IC504
IC601
IC602
IC901
IC902
IC903
IC904
IC905
IC908
5.5 Vp-p (H)
10
11
12
13
14
15
16
18
17
19
20
21
22
23
24
25
26
A
DEFLECTION)
R1817
..no
C;5'3BOOp'
I
I
II
I
B
~
I
V.l:::
5.2
-0.3
5.3
::>
7
10
11
--I
4
5
5
6
--_I
I
fC5ii5
I-
1
~":o:J-1
Ii
I
_I
---
I
RSlO7
TXD
RXO
+~v
D.(N)
'I<
sw DATA1
sw DATA2
c!«Ioa
4P
C98~
0.1
'~I.Nii
5.1
R1801
R1822
33k
33k
C1802
5Mp
8
,,~~
-
I
B
,~~~,
,j~
I
.r~~~~
.,,:.
CO
V-P06~
RO
VPCOUT
PLL 1F
v-,.,.p
1
I1...OCIC-CAP \lOUT
.r--1
-17
-
GND
"";'
"1°--t+;
!
.I
J
I'
''''
::>2::>---
- -,:::-~
v-J
'25~~
-
E-4
D-3
D-4
C-3
D-3
B-2
C-2
D-1
C-2
E-1
D-2
D-3
D-3
-=
I
'-I
'-I
C.
lLJCTTf
~'"'
CN511
DIP PIN
I
~=~
IIt;Wrl.I
1k
I
r -'---
w
- ~-
--_o=~--o-.-""-~"'~--~-~~o'~'-~,---~-=~.=~-~--'-=-~~>~>-
0__"
I
--~
~.-.:===~--~-.~~
I.J:~
I
I
t,7"
_T.o.u
~"'-::::-
~
;:~=-=---
==--~..
:-
~
~I
.1
-.
l
f"--
~u.~
~
r-
ILn
0',
B.3--
D1804
E-3
.''''''''''--r-'
I G
41
'II ~11I
r .~~:-~~::rr
I
~~"_,,,.,.,,7-,:"~---="'--""-~--~
n...,~0-
1'1
I
:-~---
=-=- --="-~
I
~~
p:rm
...-~ -~
R6 07'<'
OA7
fW
.
.
-'.0----
'-"--I
10.57
J
I
T ,eov
C,""ufb'?;.!"
T ..;;:1i
'
1opo""
_1.-:~. t.1
_=__1
,"~~;;_mW~
I I
I II
I I
.,
11~-".111111111
.F°l>1O
.I
l~cs:f-J
_I _2v_~f1-""R61~
:II
I
I
I"
~
_,_,
r-
.
~I
.d
01
-
A-3
~~:I
II1I
. I
IJ
I
r J_.-
1~9;"
C-3
_2~1t:~R9~';~.".J
::::(.
I
.l"T','
.1.1.1
.ltr~=~~~~~'T7';:II/,
I
I
-i
I~I
~--~~~--~
-
--
-----
~.-
-=
~--~
~-
Ill'l
:~~~
TO
-~
J
Jt
~cnem-ailc olai:lratil-
rDl board'"
-18
I
111I
-
'
D402
D403
__m---
'M-IT
.S-MICRO
'I r'
l
.~
:-
-U'-
II
-
C-4
C-4
C-4
C-3
C-2
A-2
B-3
B-3
C-3
C-3
r_~
.
+&VFIL T;
I
0401
0402
0403
0501
0502
Q503
0507
0510
0512
0513
OS 14
I
RU!:>.bl:::>Bl
1-5VFILT
6.""
221<
-
I..~~~;
-_J-
I-~~-
R&42
~r
~
~
---'-;'1-
A6<f6
<t~
I")~~
Oof)t::
--=~-
I
- .I
C-3
~
R6~8
'Uk
I
II
_I
I
IH'
'
..
LCI~""
~!\6;
1
I
I
m
1'111
!
~I'
:~t'f~~o,
1'010
'fir
I
.l. - Ii'
11<11
ie~'ill~I.~
.
I""u
, lit"
0.2
0.4
C
8
V S12~
VLINBAL
VLIN
H PHASE
KEy
KEy BAt..
I
.
1001>
B
~
lie CLK
IIC DATA
RE~ET
ROO2 100
C90e
--
I~.~..I 0...
.I I' II
5.21
0520
5.2 ~;'r:JjJ
R525
I
I
I
R1821
<470
f~CDr~:I.3k
I
I
~O3
I.
FI
~5~1
II
-
50.0 Vp-p (V)
IC
D BOARD DIFFERENCE LIST (* MARK)
1k
I
Q
7
.
VIMNW
R91S
I';
I
. _I.(61).',l
I
'.i2
6
- -
1.5 Vp-p (V)
@
B
.1 .!~.;~sc;J.~~1A.rR67~_J:
10.. .or
5
- -
.. .... .... .... -., -..
_.. -.. -.. -..
R915
1k
--~~
--
4
- -.-
50.0 Vp-p (H)
@
~--- -... -- -.. --
TRANSISTOR
I:) (POWER
III1,I ~'~~~:':uf
I
-----..
0
---------
SEMICONDUCTOR
LOCATION
A
....,
2.8
2.7
I
3
Vp-p (H)
@
-----
1.000
An
...
r'\
.--
D599
D601
I~
23
25
26
27
28
29
30
31
32
33
34
35
36
~7
..
U;;J;'O
3.8
0.2
8.3
4.2
2.3
2.3
7.5
4.2
3.8
0.7
5.4
2.3
C-1
E-2
E-2
T~' I ):iru-
T~I'
2
3
5
10
11
12
13
14
15
17
21
22
'''''''''--'
4 .5
6
@
-----
Pin No. Voltage [V]
*
....
V'
0602
0603
0604
r'\ nJ:.
I
Rei.
. D BOARD
D BOARD WAVEFORMS
-19
-
-20-
~
'11'
I
.
I
0'
H1{";~I
oJ,~
l~
CPD-155F2/155F2T
1)1
- DBoard-
~
A
B
c
0
E
-21 -
POWER
[ DEFLECTION
]
CPD-15SF2/15SF2T
I
A
I [VIDEO]
-
A Board
-
. A BOARD
SEMICONDUCTOR
LOCATION
IC
IC001
IC002
IC003
IC004
IC005
C-2
A-1
A-2
A-1
A-2
TRANSISTOR
0001
0002
0003
0004
0005
0101
0102
0103
0104
0105
0201
0202
0203
0204
0205
0301
0302
0303
0304
0305
B-1
A-2
A-2
0-2
A-2
0-2
C-2
C-2
G-1
0-2
0-2
0-2
0-2
0-1
0-2
0-2
0-2
0-2
0-1
0-2
B
DIODE
0002
0003
0004
0005
0010
0012
0014
0050
0101
0102
0103
0104
0105
0201
0202
0203
0204
0205
0301
0302
0303
0304
0305
A-2
A-2
A-2
A-1
B-2
0-1
B-1
A-2
B-2
B-2
0-2
C-1
C-1
B-2
B-2
0-2
C-1
0-1
B-2
B-2
0-2
0-1
0-1
CRYSTAL
X1
A-2
NOTE:
The circuit
600
Vp-p.
inspection
-22-
indicated
as left
contains
Care must be paid to prevent
or repairing.
high
voltage
an electric
of over
shock
in
CPD-15SF2/15SF2T
CPD-15SF2/15SF2T
(2) Schematic
Diagram of A Board
1
2
A
4
3
7
6
5
8
11
10
9
13
12
14
-I
A (VIDEO)
R050
47
R052
47
R~~4
+5V
ROS1
47
D107
109
B
**
" R023
+12
",,7k
D10B
CN308
,,"p
WHT
50-MICRO
GND
c
SDA
SCL
2
+5V
1
CN307
9P
WHT
. S-MI CRO
0
D
0
0
0
0
0
0
0
0
SIGNAL
0
0
0
VCC
4
R017
2.2k
9
C 205
, 01
MPS
7
FL 101
RED
6
EMI
R.GND
5
GRN
G.GND
-4
3
8LU
2
B.GND
1
C037
22
2SV
R101
24
. RN
B
GND
0
NC
3
D101
15511 9
PROT
N"
N
VS_I
0
t
R105
10011
]C005
24LC21
DOC
NC
2
0
C010
01
MPS
"
R024
+12V
R1 Q3
12k
'RN
C103
0.1 'WS
IC001
LM1207N
RGB-PRE-AMP
"*
D013
a
HS_J
D106
"
-4
3
C203 r
01
,J,.
;MP5
C035
470p
21<V
R047
100k
t
+12V
C150
0.1
C217
;J; 0.1
MP5
I
4 V5YNC
5 HSYNC
G
R164
3.91<
EMt
R201
24
RN
E
G
R162
750
12
HS_OUT
10
C SYNC
9
BPCLP
8
11
CONT
7
VRTRC
6
F810
1.1,.H
F811
1.1.H
FB12
1.1,t1.H
FB13
1.1,11H
ROO3
4
SDA
3
SCL
2
GND
1
R301
24
RN
R01-4
R309
4.7k
,RN
C091
R025
1k
100
ROD8
2.Zk
RESET
ROD9
100
SDA
I
8.r
C015
~5
I
RQ10
-BLNK
BBRT
T
~
-cu.tP
C317
01
MP5
R365
4711
J"j05
0.1
1 P'M12
PVM5
r '~~5
R30B
4711
R007
1k
ROO5
1k
R019
220
~30B
SYNC
ROB
100
R039
1k
R055
,IN (5)
SYNC
R223
22
~
;-
RO",,9
331<
R233
680
1
C214
10
C024
10
R330
1001<
RN
G)
-- --- - -----....---.--"
]C004
N...M2058D
G2/RGB
CUT OFF
MIX
R130
1001<
RN
R125
1001<
+12V
C115
01
r.PS
CONT
C315
0.1
C207
39p
CH
R232
2.2k
RN
C30B
68p
500V
CH
R012
100
IC002
TC7""HC02AP
CLAMP INV/BLANK
R211
1.5k
FPRD
0201
25oA120B-K
G-BUFF
D203
15050119
RVOO1
471<
it
I'
0.5 Vp-p (H)
R362
750
0505
25oC:5311A
M] x
B-oSD
R364
3.9k
R323
22
R306
680
R325
100k
R363
1.51<
I
I@
- -..- - --- - -
@
0.5 Vp-p (H)
R207
120
FPRD
5~0:
R225
1001<
2~~~~9A
ON G-SEPARATER
@
-.. ---- --.'--Jo.oJ1----M~--
C206
68p
R226
680
'10V
~5Ad-3s~9pAARATER
4.0 Vp-p (H)
- ..J- -J --/..--,1.-_..
R20B
660
3.911
R011
6Bk
QOO~
R~2707
R264
STBY
+1 'LV
STBY+15V
C007
",,7
16V
'...
"",
3.8 Vp-p (H)
°p~r
C016
4.7
0.5 Vp-p (H)
.--- --""""." ...."....
-..."'--""--"--It.
110
1
10
R262
750
ROO,,"
3311
@
R132
2.2k
RN
C1H
PWM4
+12V
STBY
",.."
R112
560
5CL
0.'
twPS
C006
47p
CH
C107
27p
CH
C113
STBY+5V
.",J~.",,."'/""f'
K
5CL
PVlM3
A BOARD
J
XTALI
R303
MPS 47k
BDR I v
C303
0002
155119
~
R133
680
2201<
100
I
R111
1.5k
FPRD
R115
390
R022
R001
1k
WAVEFORMS
D103
155119
R310
4.711 'RN
R20B
4711
~sr
R027
47k
~. ~S
SCL
FBD14
1.1,11H
R104
100
RESET
R302
51
.RN
SDA
D004
RD5.BESB2
CD
H
Q105
2&3311
A
R-050
t.11lx
R125
22
D003
155119
47k
50
RESET
,,,,"""''''''
R163
1.511
GND
EM I
C-BLA.NK
VS_OUT
H.RETRACE
....,lit
C106
68p
500V
CH
R126
680
6 VDD
7 P]XCLK
.
R106
680
FL301
CN30S
1ZP
WHT
5-M[CRO
F
R202
51
RN
R021
101<
R020
1 Ok
ROOB
101<
FL201
TO
D BOARD
CN50B
C250
1
3 FBLK
R018
470
~-
,.
...
3.8 Vp-p (H)
(j)
@
@
@
AMM
-..----------,.
,..
---"----..--.
-...
-...
- - - -.
-- - ---
7.0 Vp-p (H)
2.4 Vp-p (V)
2.4 Vp-p (V)
2.4 Vp-p (H)
........
.....--......-
....,.....
-- --- -
---
"
B-DC
D303
1550119
LEVEL SH I FT
R311
1.5k
FPRD
R515
390
STBY
+5V
-24-
C307
~6p
CH
R304
100
R333
680
'"
05
-23-
t
~006k""
1
SGOO1 SG301
/R~
IC003
SNY422-5ONY
05D
r
R102
51
RN
IN
15
C314
10
R532
2.2k
RN
I
t
5G201
t
5G101
R048
2.2M
1W
HV
SECTION
EXPLODED
5-4.
SEMICONDUCTORS
HD74HC123AP
D8LC20U
2SA1206-K
9
16
DTC124ES
c::::]
2SA1206-K1
.
j
8
CTCJ' VIE'tIJ
~0
IRFI9630G-LF
SB340
(.!.~
(+) 3
~
1
Items
.
description
are not stocked because they
are seldom required for routine service.
The construction
parts of an assembled
with
no part
part are indicated
in the remark
-\~)j-(-)
6-1.
with a collation
SCREW
SCREW
7 -685-648-79
7-685-663-79
b.
,
marked"
" are not stocked since
they are seldom
required
for routine
se rv ice.
So m e de I ay s ho u Id be
anticipated when ordering these items.
NOTE:
{'~'
The components
identified by shading
and mark Lt:. are critical for safety.
Replace only with part number specified.
6-2.
PACKING
MATERIALS
number
@
les composants
identifies
per un trame
et une marque
Lt:. sont critiques
pour la
securite.
Ne les rem placer que par une
piece portant
Ie numero
specifie.
+BVTP
+BVTP
3X12
4X16
~
SB340L-6489
~~
ANODE
I~
~
EGP10G
RD10ES-B2
RD12ES-B2
RD15ES-B2
RD18ES-B2
RD27ES-B2
RD2.7ES-B2
RD4.7ES-B2
RD5.6ES-B1
RD5.6ES-B2
RD6.8ES-B2
1SS119
5
2SB1094-LK
~~:::::::I
.
IRFPC40
/
()
. Items
no
CHASSIS
.
... ..
RH-1A
IJI
14
and
VIEWS
column.
IRFPE40LF20
IRLI530G
MC14066BCP
SN74HC02AN
NJM2058D
number
6
(.!.~
EGP10D
2SA1540-DE
.
''')
(-)
or
E B
LA6500-FA
D
CPD-15SF2/15SF2T
CPD-15SF2/15SF2T
CPD-15SF2/15SF2T
.~
~~
~
~
---::::e;
~
U05G
fTOP VIEWI
NJM2903D
TL082CP
8
7
0
I
2
6
ANODE
BC\
5TUZ52
2SC2611
2SC3955-DE
5
GD
CA THDIIE
s
LETTER
SIDE
IRF614
2SK1904
3
ANDIIE
4
GBU4JL-6088
(TOP VIE'tIJ
~TDA8172
E
8 C E
SEl1422G
SEL 1922D-C
C B
~2SC2785-HFE
2SC3311A
2SA1175-HFE
2SA1309
2SC2001
2SC2001-LK
PST600D-T
Lt.tur
.,..
C
B
E
2SK738
~!~GATE
GP08D
GP08DPKG23
HSS82
RGP02-20EL-6394
UF3ML-6505
UF4007G23
1SS82
1SS83
3DL41A
KTHODE
~
G/!
s
-26-
~,
REF.NO. PART NO.
1
2
3
4
.."pc"c
X-4032-970-1
3-571-801-01
4-045-116-01
4-045-123-01c
ANODE
CATHODE
5
6
REMARK
BEZEL ASSY
SPRING, COMPRESSION
BUTTON, POWER
HOLDER. DEGAUSSING
2,3
,Ai'
cCC..
CCC
C
C
C
CCCCC
cCcc..cc
SCREW
(5),
11
11
12
COil
CCCCCCCCCCCCCCCCCCC
CCC
C CCCC
cC""
CCC
C
C,cC,C,
,C', CcC,
Cc"
CC
TAPPING
13
..tt1#$2+.7$$aJ..NeCKA$$YI~IG1Q!3emU~e(NA~S$)c.c
.
'A-1292-901-B
A BOARD, COMPLETE
[for Japan-made
set)
'A-1297-587-B
A BOARD,
COMPLETE
(US/CND)
'A-1297-626-B
A BOARD, COMPLETE
[for UK-made
set)
'4-050-329-01
CUSHION,
(A)
4-369-:31a~QO SPRING. TENSION
,C,,14
"c, C.c&;b40~79!h1fOQIL'PI$MAGNSlt~110N
15
16
4-045-113-01
'A-1346-408-A
CABINET
D BOARD, COMPLETE
16
'A-1346-411-A
D BOARD,
'A-1346-419-A D BOARD, COMPLETE
C
18
19
4-389-025-01
'4-045-131-01
SCREW (M4X8) (EXT TOOTH WASHER)
STOPPER, CABLE
20
21
22
23
24
'4-045-130-01
4-381-962-11
1-775-535-21
4-045-121-01
4-045-114-01
BRACKET, CABLE
SCREW +BVTT 4X8 (S)
CABLE ASSY
STOPPER (A), STAND
COVER, BOTTOM (except for US/CND)
24
25
26
27
28
4-045-114-11
4-045-122-01
X-4032-051-1
4-308-870-00
1-452-032-00
COVER, BOTTOM
RING, TilT SWIVEL
BASE ASSY, STAND
CLIP, lEAD WIRE
MAGNET,
DISC
29
30
31
1-452-094-00
MAGNET,
X-403-058-41
'4-046-834-01
31
32
'4-050-730-01
4-048-148-01
..
COMPLETE
set))
'A1346-447-ADBOARD,COMPlETE
115SF2T)
)7,
..~~:W$~t~7i~m~~~~7~~F~~~r1;~l~~r~/jjj~).
4~090:492-01
CSPACER.
DY
CC..~CC..C.
ccc.
&$i451+46~~~1)pE$~4e(::t'()NYOKeYi$Faf~M~cc
itO...
11
REMARK
(AEP [for UK-made
c.4i:!:F~4~829~Q5el~;r\JRETUBE'5FR2rSlPyr
C,CCC"
'..C,
,'.c cc\
c.<
..'c 'CC.ccc.,'c,.c.'.'
"C"{M$~L.~J'$)()JAQ$)
»
4~365-808-01c
DESCRIPTION
16
..CC",
c.c.~~r731;~O'P?P'ptYRF0P~e..'~~rel~i:~~I~$F~n
REF.NO. PART NO.
16
.'..~8J~~c8~$~~PII~~sj;~~~~~=~~&$;15$~Ti
C
ji..c
DESCRIPTION
ROTATABLE
PART NO.
DESCRIPTION
51
3-800-818-11
MANUAL,
51
3-800-818-21
15mm<l>
CONVERGENCE
51
52
52
3-800-818-31
1-765-717-11
1-765-718-11
set))
set)
53
54
(US/CND)
REF.NO.
10mm<l>
DISK
PERMAllOY
ASSY,
LABEL, X-RAY
(except for [for UK-made
LABEL, X-RAY
[for UK-made
STOPER
(B)
'4-045-089-01
'4-041-927-11
REMARK
REF.NO.
INSTRUCTION
(15SF2 [AEP, ES, AUS))
MANUAL, INSTRUCTION
(15SF2 [US/CND))
MANUAL, INSTRUCTION
(15SF2T)
CORD SET, POWER (except for US/CND)
CORD SET, POWER
(US/CND)
54
55
CUSHION (UPPER) (ASSY)
BAG, POLYETHYLENE
(except for US/CND)
[for Japan-made
set)
(US/CND)
-27-
-28-
PART NO.
DESCRIPTION
REMARK
56
4-380-340-01
'4-045-088-01
'4-045-090-01
BAG, POLYETHYLENE
PAT, TilT FIXED
CUSHION (lOWER) (ASSY)
(US/CND)
57
57
57
'4-050-991-01
'4-050-995-01
'4-050-996-01
57
'4-050-997-01
(US/CND)
INDIVIDUAL CARTON
(15SF2T)
INDIVIDUAL CARTON
INDIVIDUAL CARTON
(AEP [for Japan-made set], ES, AUS)
INDIVIDUAL CARTON
(AEP [for UK-made set))
CPD-15SF2I15SF2T
SECTION
ELECTRICAL
PARTS
LIST
The components
identified
by B in this
manual
have been carefully
factoryselected for each set in order to satisfy
regulations
regarding
X-ray radiation.
NOTE:
:~~r::~:::::::::::::~::~:::::~::::~:::::::::::::::::::::::::::::::~:::::~::::::::::::::::::::::::::::::::::::::::::x::~::::::::::::::::~:::::::::~:~:::::::::::~~~~j,
@ The
components
identified
by shading
\1j and mark .& are critical for safety.
Replace
only with part number
specified.
7
:@
:@
!;!
::::::::::::::::::::~:::::::::::::::::::::::::::::::::::::::::::::::::::::~:::::::::::::::::::::::::::::::~:::::::~::::~:::::::~::::::::::::::::::::::::::::::::::~:::~::::
ili!
Should replacement
be required, replace
only with the value originally used.
,:~~::::::::::::::~:::::::::::::::::::::::::::::::::::;:;:;:;:;:;:;:;:;:;:;:;:;:::;:::;:;:;:;:;:;::$::;:;:;:~:~::::::::::::~:::::::::~::::::::::::::::::::::::::::~:::~~~~~'
:11
Les composants
1
et une marque
:::j
ill:
identifies
& sont
per un trame
critiques
:I::
pour la
securite. Ne les rem placer que par une
piece portant Ie numero specifie.
1
:@
.
ti
indicating
please
include
REF.NO.
PART
parts
by reference
the board
NO.
* A-1292-901-B
and adjustable
characteristic
curve
have
Items marked"
they
are seldom
service.
anticipated
* " are not stocked since
required
for routine
Some
delay
should
be
when ordering these items.
B, unless
otherwise
REF.NO.
PART NO.
C104
C105
C106
C107
C109
1-136-165-00
1-136-165-00
1-107-608-11
1-102-961-00
1-102-119-00
FILM
FILM
CERAMIC
CERAMIC
CERAMIC
0.111F
0.111F
68pF
27pF
0.001511F
5%
5%
5%
5%
10%
50V
50V
500V
50V
50V
C111
C112
C113
C114
C115
1-126-967-11
1-102-117-00
1-136-165-00
1-126-964-11
1-136-165-00
ELECT
CERAMIC
FILM
ELECT
FILM
4711F
820pF
10l1F
0.111F
20%
10%
5%
20%
5%
16V
50V
50V
50V
50V
C116
C150
C201
C203
C204
1-102-074-00
1-136-165-00
1-126-964-11
1-136-165-00
1-136-165-00
CERAMIC
FILM
ELECT
FILM
FILM
0.00111F
0.111F
10l1F
0.111F
0.111F
10%
5%
20%
5%
5%
50V
50V
50V
50V
50V
C205
C206
C207
C208
C209
1-136-165-00
1-107-608-11
1-102-965-00
1-136-165-00
1-102-121-00
FILM
CERAMIC
CERAMIC
FILM
CERAMIC
0.111F
68pF
39pF
0.111F
0.002211F
5%
5%
5%
5%
10%
50V
500V
50V
50V
50V
C212
C214
C215
C216
C217
1-102-074-00
1-126-964-11
1-136-165-00
1-136-165-00
1-136-165-00
CERAMIC
ELECT
FILM
FILM
FILM
0.00111F
10l1F
0.111F
0.111F
0.111F
10%
20%
5%
5%
5%
50V
50V
50V
50V
50V
C250
C301
C303
C304
C305
1-124-903-11
1-126-964-11
1-136-165-00
1-136-165-00
1-136-165-00
ELECT
ELECT
FILM
FILM
FILM
111F
10l1F
0.111F
0.111F
0.111F
20%
20%
5%
5%
5%
50V
50V
50V
50V
50V
C306
C307
C308
C309
C312
1-107-608-11
1-101-884-00
1-136-165-00
1-102-119-00
1-102-074-00
CERAMIC
CERAMIC
FILM
CERAMIC
CERAMIC
68pF
56pF
0.111F
0.001511F
0.00111F
5%
5%
5%
10%
10%
500V
50V
50V
50V
50V
C314
C315
C316
C317
1-126-964-11
1-136-165-00
1-107-943-11
1-136-165-00
ELECT
FILM
ELECT
FILM
10l1F
0.111F
10l1F
0.111F
20%
5%
20%
5%
50V
50V
160V
50V
number,
name.
REMARK
DESCRIPTION
A BOARD,
COMPLETE
****************************
[for Japan-made
* A-1297-587-B
resistors
RESISTORS
All resistors are in ohms
F : nonflammable
.
.
.
noted.
~~~;=:::::::::::::~::::::~:~:::~~:::::::::::::::::::::::;:~::::::::~::"::::::::::::::::::::::::::~:::::::::::::~::::::::::~:::::::::::;::::::::::::::::::::::::::::~:~~:
When
All variable
[A]
A BOARD,
set]
COMPLETE
(US/CND)
DESCRIPTION
REMARK
****************************
*
A-1297-626-B
*4-045-124-01
4-382-854-11
A BOARD,
COMPLETE
************************'1'***
[for UK-made
set]
COVER, VIDEO
SCREW (M3X10), P, SW (+)
(0102,0104,0202,0204,0302,0304)
CAPACITOR
C001
C002
C004
C006
C007
1-126-933-11
1-102-951-00
1-136-165-00
1-101-880-00
1-126-967-11
ELECT
CERAMIC
FILM
CERAMIC
ELECT
100l1F
15pF
0.111F
47pF
4711F
20%
5%
5%
5%
20%
16V
50V
50V
50V
16V
C010
C011
C012
C013
C015
1-136-165-00
1-126-967-11
1-126-935-11
1-126-935-11
1-136-165-00
FILM
ELECT
ELECT
ELECT
FILM
0.111F
4711F
470l1F
470l1F
0.111F
5%
20%
20%
20%
5%
50V
16V
16V
16V
50V
C016
C017
C022
C023
C024
1-124-927-11
1-136-165-00
1-126-933-11
1-126-964-11
1-126-964-11
ELECT
FILM
ELECT
ELECT
ELECT
4.711F
0.111F
100l1F
10l1F
10l1F
20%
5%
20%
20%
20%
50V
50V
16V
50V
50V
C029
C031
C034
C035
C036
1-126-964-11
1-162-318-11
1-162-318-11
1-162-134-11
1-102-951-00
ELECT
CERAMIC
CERAMIC
CERAMIC
CERAMIC
10l1F
0.00111F
0.00111F
470pF
15pF
20%
10%
10%
10%
5%
50V
500V
500V
2KV
50V
C037
C038
C044
C055
C088
1-128-551-11
1-137-370-11
1-136-165-00
1-102-951-00
1-126-933-11
ELECT
FILM
FILM
CERAMIC
ELECT
2211F
0.0111F
0.111F
15pF
100l1F
20%
5%
5%
5%
20%
25V
50V
50V
50V
16V
C091
C092
C100
C101
C103
1-136-165-00
1-136-165-00
1-126-967-11
1-126-964-11
1-136-165-00
FILM
FILM
ELECT
ELECT
FILM
0.111F
0.111F
4711F
10l1F
0.111F
5%
5%
20%
20%
5%
50V
50 V
16V
50V
50V
0.1111='
CONNECTOR
CN301*1-506-108-41
-29-
PIN, CONNECTOR
(TERMINAL
PIN)
CPD-15SF2/15SF2T
:~r:i::::'::;;;::::::::::-~::::~:=..~::::::::::::::::$:$*::::::::-*-*=m:::::::::~::::::::::::::-~::-~~::::::::::::$:::::::::::~if:
::::::~?';:::='::::::$;:::;::.-::::::::m:W::*::::::::::::-~::'?'::*'::":":::-*:;;'::$::::::::::;::::::::W2-::::$::
t
f
[A]
f:~
Les composants
et une marque
s6curit6.
&
identifi6s
per un tram6
sont critiques
pour la
Ne les remplacer
que par une
r
[1!1
if l
1~!
The components
and mark
iJ Replace
&
identified
by shading
are critical for safety.
only with
part
number
specified.
~j
~ij
i~:
~~~:::~:$::~:::"*=:::::~::::::::::::::::::~~;~::$;-::::::::~:$:::;::;~:::::~;::;::::::-;:::x:~::~~::::;::;:::"::::::~-::::::.~::
It:;:~~:,~,~~~:~;:,:::;:~:;::;~;:::::~~:~:~~::::;~::;:::":;:;:,,:;:;,,JI
REF.NO. PART NO.
REMARK
DESCRIPTION
REF.NO.
PLUG,
PLUG,
CN307*1-564-512-11
CN308*1-564-507-11
PLUG, CONNECTOR
PLUG, CONNECTOR
NO.
DESCRIPTION
REMARK
IC
1-695-915-11 TAB (CONTACT)
CN303 1-695-915-11 TAB (CONTACT)
CN302
CN305*1-564-514-11
CN306*1-564-515-11
PART
11P
12P
CONNECTOR
CONNECTOR
IC001
IC002
IC003
IC004
IC005
9P
4P
DIODE
8-759-335-25
8-759-232-03IC
8-759-348-09
8-759-711-28
8-759-338-37
IC LM1207
TC74HC02AP
IC SNY 422-S0NY
IC NJM2058D
IC 24LC211/P
JACK
D002
D003
D004
D005
D010
8-719-911-19
8-719-911-19
8-719-109-89
8-719-911-19
8-719-911-19
DIODE
DIODE
ZENER
DIODE
DIODE
1SS119-25
1SS 119-25
DIODE RD5.6ESB2
1SS119-25
1SS119-25
D012
D014
D050
D101
D102
8-719-109-97
8-719-911-19
8-719-911-19
8-719-911-19
8-719-911-19
ZENER
DIODE
DIODE
DIODE
DIODE
DIODE RD6.8ESB2
1SS119-25
1SS 119-25
1SS119-25
1SS119-25
D103
D104
D105
D201
D202
8-719-911-19
8-719-970-83
8-719-970-83
8-719-911-19
8-719-911-19
DIODE
DIODE
DIODE
DIODE
DIODE
1SS119-25
HSS82
HSS82
1SS 119-25
1SS119-25
0001
0002
0003
0004
0005
8-729-032-61
8-729-119-76
8-729-119-76
8-729-326-11
8-729-119-78
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC5022-02
2SA1175-HFE
2SA1175-HFE
2SC2611
2SC2785-HFE
D203
D204
D205
D301
D302
8-719-911-19
8-719-970-83
8-719-970-83
8-719-911-19
8-719-911-19
DIODE
DIODE
DIODE
DIODE
DIODE
1SS119-25
HSS82
HSS82
1SS119-25
1SS 119-25
0101
0102
0103
0104
0105
8-729-103-19
8-729-019-70
8-729-031-84
8-729-823-07
8-729-119-78
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SA1206-K1
2SC3955-DE
2SC3652
2SA1540-DE
2SC2785-HFE
D303
D304
D305
8-719-911-19
8-719-970-83
8-719-970-83
DIODE 1SS119-25
DIODE HSS82
DIODE HSS82
0201
0202
0203
0204
0205
8-729-103-19
8-729-019-70
8-729-031-84
8-729-823-07
8-729-119-78
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SA1206-K1
2SC3955-DE
2SC3652
2SA1540-DE
2SC2785-HFE
0301
0302
0303
0304
0305
8-729-103-19
8-729-019-70
8-729-031-84
8-729-823-07
8-729-119-78
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SA1206-K1
2SC3955-DE
2SC3652
2SA1540-DE
2SC2785-HFE
FERRITE
FB001
FB002
FB003
FB004
FB005
1-412-911-11
1-412-911-11
1-412-911-11
1-412-537-31
1-412-911-11
::{:J.Q~h}lj~g~U$$.aM$IQKIM;Le1!c.tql(MtQ"i::::!:j:::JJj:;}:!'j}:;}:ff::J::::::J:
COIL
L102
L202
L302
.
FERRITE
FERRITE
FERRITE
BEAD
BEAD
BEAD
FERRITE
BEAD
INDUCTOR
INDUCTOR
INDUCTOR
1j.tH
1j.tH
1j.tH
TRANSISTOR
BEAD
INDUCTOR,
INDUCTOR,
INDUCTOR,
INDUCTOR
INDUCTOR,
1-414-142-11
1-414-142-11
1-414-142-11
100j.tH
RESISTOR
FB006 1-412-911-11 INDUCTOR, FERRITE BEAD
FB0071-412-911-11INDUCTOR,FERRITEBEAD
FB008 1-535-303-00 LEAD, JUMPER (5.0MM)
FB010 1-410-397-21 FERRITE BEAD INDUCTOR
FB011 1-410-397-21 FERRITE BEAD INDUCTOR
1.1j.tH
1.1j.tH
FB012
FB013
FB014
1.1j.tH
1.1j.tH
1.1j.tH
1-410-397-21
1-410-397-21
1-410-397-21
FERRITE
FERRITE
FERRITE
BEAD INDUCTOR
BEAD INDUCTOR
BEAD INDUCTOR
FILTER
FL001
FL002
FL 101
FL201
FL301
1-421-995-11
1-249-413-11
1-239-973-11
1-239-973-11
1-239-973-11
FILTER,
CARBON
FILTER,
FILTER,
FILTER,
NOISE
470
EMI
EMI
EMI
5%
1/4W
R001
R002
R003
R004
R005
1-249-417-11
1-215-438-00
1-249-437-11
1-249-435-11
1-249-417-11
CARBON
METAL
CARBON
CARBON
CARBON
1K
5.1K
47K
33K
1K
5%
1%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R006
R007
R008
R009
R010
1-249-429-11
1-249-417-11
1-249-421-11
1-247-807-31
1-247-807-31
CARBON
CARBON
CARBON
CARBON
CARBON
10K
1K
2.2K
100
100
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R011
R012
R013
R014
R015
1-249-439-11
1-247-807-31
1-247-807-31
1-247-807-31
1-215-887-00
CARBON
CARBON
CARBON
CARBON
METAL OXIDE
68K
100
100
100
150
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
2W
-30-
F
-31 -
CPD-15SF2/15SF2T
:::::::::::::::::::::~:~::::::~~:::::::~::~::::::~::~::~::~::~::~::~::::::~::::;::::::::::::::::::::::::;:::::::::::::::::::::::::::;::::::::;:;:
!~~t::::::::::::::::::::;:::;:;$;:::;:::;:::::::;:::;:;::::$:::::::::::::::$::::::::::;::::::::::::::::::::::::::::$::::;:;:::;:::::::::::::::~~~~
~
~
:t Les
[AJ~
composants
identifies
per un trame
et une marque &. sont critiques pour la
t: securite.
Ne les remplacer que par une
it piece portant Ie numero specifie.
m:
r~ The components
@
identified
by shading
t: and mark &. are critical for safety.
::::
M
t
iiiil,:,:::::~:.::,:,~,::,;,:;:,i:,::,~::::,::;~;::~:::,:~:.~::::::~:;:,:,iiii:
-~~~~j::::::::::::::;::::::::::::::::::::::::::::::::::::::::;:;:::;:;:;:;:;:::;:;:;:;:;:;:;:;:;:;:::;:::;:::;::::::::::::::::::::::::::::::::::::::::::J~j
REF.NO.
PART
NO.
DESCRIPTION
REMARK
REF.NO.
PART NO.
C405
C406
C407
C408
1-136-173-00
1-137-375-11
1-126-964-11
1-126-964-11
FILM
FILM
ELECT
ELECT
0.47jlF
0.068jlF
1OjlF
10jlF
5%
5%
20%
20%
50V
50V
50V
50V
C409
C410
C411
C412
C413
1-124-903-11
1-126-964-11
1-102-112-00
1-101-810-00
1-126-964-11
ELECT
ELECT
CERAMIC
CERAMIC
ELECT
1jlF
1OjlF
330pF
100pF
1OjlF
20%
20%
10%
5%
200/0
50V
50V
50V
500V
50V
C414
C415
C501
C503
C504
1-137-370-11
1-107-714-11
1-104-664-11
1-107-667-11
1-104-664-11
FILM
ELECT
ELECT
ELECT
ELECT
0.01jlF
1OjlF
47jlF
2.2j.tF
47jlF
5%
20%
20%
20%
20%
50V
16V
25V
160V
25V
C505
C506
1-107-974-11
1-136-105-00
CERAMIC
FILM
47pF
0.33jlF
5%
5%
2KV
200V
R333
R334
R350
1-249-415-11
1-215-477-00
1-249-413-11
CARBON
METAL
CARBON
680
220K
470
5%
1%
5%
1/4W
1/4W
1/4W
R351
R362
R363
R364
R365
1-202-549-00
1-215-418-00
1-249-419-11
1-249-424-11
1-249-437-11
SOLID
METAL
CARBON
CARBON
CARBON
100
750
1.5K
3.9K
47K
20%
1%
5%
5%
5%
1/2W
1/4W
1/4W
1/4W
1/4W
VARIABLE
RESISTOR
RV001
1-241-787-11
SPARK
SG001
SG101
SG201
SG301
RES,
ADJ,
CARBON
GAP,
GAP,
GAP,
GAP,
SPARK
DISCHARGE
DISCHARGE
DISCHARGE
47K
i$ij~m:~ilij~t~1:~ji::~j~t::
C510
1-128-526-11 ELECT
CRIST AL
1-567-890-11
VIBRATOR,
CRYSTAL
********************************************************************************
.
A-1346-408-A
D BOARD, COMPLETE
****************************
[for Japan-made
.
REMARK
GAP
1-519-422-11
1-519-504-11
1-519-504-11
1-519-504-11
X1
DESCRIPTION
A-1346-411-A
D BOARD,
C511
C512
C513
C514
C515
1-137-370-11
1-137-370-11
1-106-391-12
1-101-006-00
1-106-228-00
FILM
FILM
MYLAR
CERAMIC
MYLAR
0.01jlF
0.01jlF
0.1jlF
0.047jlF
0.22jlF
5%
5%
10%
10%
50V
50V
200V
50V
100V
C516
C517
C518
C520
C521
1-137-399-11
1-107-894-11
1-102-002-00
1-126-942-61
1-128-528-11
FILM
ELECT
CERAMIC
ELECT
ELECT
0.1jlF
220jlF
680pF
1000~lF
470jlF
5%
20%
10%
20%
20%
50V
35V
500V
25V
25V
C522
C523
C524
1-137-374-11
1-137-399-11
1-124-903-11
FILM
FILM
ELECT
set)
COMPLETE
(US/CND)
****************************
. A-1346-419-A
:::;.mmmm~ft~ff:f::m:i:\l:ivm~:
100jlF
20% 25V
... G.Ei2Ej
D BOARD, COMPLETE
.1.~ 1.:2.E5~.~E5.4:~11.E:q;QT...
H.
0.047jlF
5%
50V
0.1jlF
5%
50V
1jlF
20%
50V
HHHHH1()I:lFHHHH.?().0(~H50VHH
m)m)Q;~~r':::$r.~mOOY::
P$~~m~H$.mtmH~!fIt'tMm
****************************
(AEP
.
A-1346-447-A
[for UK-made
set))
m~~~:m.~ili:j~ij+,~~jj.glt«t::~:.(tmm~~g.jJ:::~;@~~:m~Ml::::
C532
1-106-367-00 MYLAR
0.01jlF
10%
C533
1-101-821-00 CERAMIC
0.0022jlF
C534
1-162-978-11 CERAMIC
0.01jlF
D BOARD, COMPLETE
****************************
(15SF2T)
1-533-223-11
4-045-132-01
4-045-133-01
4-047-285-01
4-382-854-11
HOLDER, FUSE (F601)
HOLDER (A), LED
HOLDER (B), LED
SHEET, INSULATING (0510)
SCREW (M3X10), P, SW (+) (0503, 0507,
0510,0602,
IC504, IC602, D501, D601)
4-389-025-01
4-389-026-11
SCREW
SHEET,
(M4X8)(EXT
BN (0602)
C535
C536
... G.Ei4()
CERAMIC
CERAMIC
.1.~1.:3.E5~.Ei:3.~~.11H
FILM
... G5.48
1-102-973-00
1-137-364-11
1-126-941-11
CERAMIC
FILM
ELECT
CAPACITOR
.~&da~~~MfSUM~t)
~4iMj$.$.~iQ~jjffl4M
0.001jlF
15pF
Q.~1Mf
::q;~nmF:t
10% 500V
5%
2KV
§"!~9.gy .
.'. .%. :':i.!:i.!ID
",,.,..~..::ii
:t~ltt. :.!::i:".. .. : ";,
. ::.:: . :..
.. . .:
,,
'. , .. ;;, ; ,...
,
:,~y
::, :,.:,_Vf<>
. .:: .
.
.
:.
,,
.
...
, .' , .
, :, :,:.
: ::::
.
::.Q;QQQtpjF:~o/~.$@V}
10%
2KV
2KV
.9.()og2jlF...
.:3%
:2.KV......
100pF
0.001jlF
470jlF
5%
5%
20%
50V
50V
25V
.1.~1:37 ~.4:2.5.~.1.1. FIL,M.....
~:::.~@iMt~'N~$!1iU:~!~:
C077
1-162-318-11 CERAMIC
C079
1-109-878-11 CERAMIC
HG4011~137-:3!:J9-.1.1. flL,M
~~iQgim:M1$.1A3.:'tQ@JFj!iM\
0.001jlF
0.01jlF
i:ill'li~~~~~8~~~.!lli.:..;..;.::;.:.i:i!.i.!iii!.'i!.'.~;~~I~!i::il..lll\'!..;i
C543
C544
C547
TOOTH WASHER)
1-161-754-00
1-162-978-11
200V
500V
2KV
;:m~;i~'mf
f~;;::f~Ml:ff
C550
C551
C562
C563
C565
1-109-960-11
1-102-106-00
1-136-946-11
1-102-110-00
1-136-244-11
FILM
CERAMIC
FILM
CERAMIC
FILM
0.43jlF
100pF
0.12jlF
220pF
0.1jlF
5%
10%
5%
10%
5%
400V
50V
200V
50V
50V
C567
C569
1-136-121-00
1-137-370-11
FILM
FILM
0.27jlF
0.01jlF
5%
5%
200V
50V
:
-32-
t~
l:
CPD-15SF2/15SF2T
..
...
::;:::;:::;:;:::::::;:;:;:;:;:::;:::;:::;:::::::;:;:;:::;:;;"{;:;:;:::;:::;:::~::::;:;:;:::;:~::~;:~;:::::::::::~::::::~::::::::~::;:::::::::~::::::::
:;:;:;:;:;:;:;:;:;~:;::~:::;::::~~:;:::::::::::::::::~::~::::::::::::~::::::::::::::::::::::::::::::::::::::;:::;:::;:::::::::;:~;:::::::::::::;~::::.
m
The components
m
and mark
Replace
.:t
identified
are critical
by shading
for safety.
only with part number specified.
[
11
't
Les composants
11 et une marque.:t
H securite.
identifies per un trame
sont critiques pour la
Ne les rem placer
::!:
I:::
:~::::;:;:;:;:::;:;:;:;:;:::;:;:::;:;:;:;:;:;~:;:::;:;:::;:;:;:;:::;:;:;:;:::;:;:::;:;:::;:::;:;:;:;:;:;:::;:;:::;:;:;:;:;:;:;:;:;:;:;:;:;::::$::;:;:;:;
piece portantle
numero
que
par une
specifie.
I::;:;:;:;:;:;:;:;:;:;:;:;:;:;:;:;:;:;:;:;:;:;:;:;:;:;:;:;:;:;:;:;~:;:;:::::::::::::=:::=:::=::::::~::::::::::::::::::::::::::~:::::;:::::;:;:;:;:;:~;:;:;:;
REF.NO. PART NO.
C570
C571
C573
1-136-853-11 FILM
1-124-903-11 ELECT
1-137-364-11 FILM
C577
1-102-106-00
C578
1-126-952-11
G.i~pttjM~ii~7Mjfflqij?
C581
1-137-399-11
C582
1-161-754-00
C583
CERAMIC
ELECT
... G!59~
1-102-106-00
1-136-105-00
1-137-365-11
1-137-370-11
1-102-114-00
CERAMIC
FILM
FILM
FILM
CERAMIC
.1.~~ Q4:E)13!5:1.1. .~l,E~GT...
{~1a:\HjQti$a;Hd~JW/
.~mjWpiblQijf$jFj~&f\
'~~;$1M@?S$t?}$1(!gRAM!q}
.4a:\jnt$~~t~*Mqe.~\M;M1O:
:~$~jM~~~miQf$1:gl@~Mi9J
.$$Hn$S$QQf~tQ~fflAM!O{
[Q]
:I
REF.NO. PART NO.
DESCRIPTION
REMARK
5%
20%
5%
200V
50V
50V
C902
C903
C904
1-137-366-11 FILM
1-102-951-00 CERAMIC
1-137-399-11 FILM
0.00221LF 5%
15pF
5%
5%
0.11LF
100pF
10%
20%
50V
16V
.. . ......
"...',..,...,.,.,.
C905
C906
C907
C908
C909
1-137-399-11
1-137-399-11
1-124-927-11
1-102-951-00
1-102-106-00
FILM
FILM
ELECT
CERAMIC
CERAMIC
0.11LF
0.11LF
4.71LF
15pF
100pF
5%
5%
20%
5%
10%
50V
50V
50V
50V
50V
5% 50V
20% 50V
C911
C912
C916
C917
C918
1-126-768-11
1-136-165-00
1-124-925-11
1-124-925-11
1-124-925-11
ELECT
FILM
ELECT
ELECT
ELECT
2200llF
0.11LF
2.21LF
2.21LF
2.21LF
20%
5%
20%
20%
20%
16V
50V
50V
50V
50V
10%
5%
5%
5%
10%
C919
C920
C921
C922
C923
1-124-925-11
1-124-925-11
1-124-925-11
1-137-399-11
1-137-370-11
ELECT
ELECT
ELECT
FILM
FILM
2.21LF
2.21LF
2.21LF
0.11LF
0.011LF
20%
20%
20%
5%
5%
50V
50V
50V
50V
50V
C924
C925
C926
C928
C929
1-137-399-11
1-126-934-11
1-137-364-11
1-137-370-11
1-137-399-11
FILM
ELECT
FILM
FILM
FILM
0.11LF
220ILF
0.0011lF
0.011LF
0.11LF
5%
20%
5%
5%
5%
50V
16V
50V
50V
50V
C930
C931
C932
C933
C934
1-124-768-11
1-136-169-00
1-137-399-11
1-126-934-11
1-124-925-11
ELECT
FILM
FILM
ELECT
ELECT
4.71LF
0.221LF
0.11LF
220ILF
2.21LF
20%
5%
5%
20%
20%
35V
50V
50V
16V
50V
C935
C936
1-136-169-00 FILM
1-137-399-11 FILM
.. .1.90QflF=..
..... ." .." .............. y ,...
5.0
::::..'..:.:~K::::::::::..',..',.::.,::::::::
1-106-375-12 MYLAR
:t
:t
0.561LF
1ILF
0.0011LF
:O)t!o$ii!t 5 ~
FILM
CERAMIC
'~~$.:ij*j~~8i~~~i~~ij~MI~
C587
1-137-399-11 FILM
C590 1-126-965-11 ELECT
C591
C593
C594
C595
C596
REMARK
DESCRIPTION
1}
5% 50V
10% 2KV
0.11LF
0.0011LF
0.0221LF
J5QpF=..
:}~@j:ffit
0.11LF
22ILF
10% 100V
....!5%
100pF
0.331LF
0.00151LF
0.011LF
470pF
!>.CJV.....
jp$)$.jpM}
50V
200V
50V
50V
50V
..1 ().CJI!F=.. ....20%.. ..2.!5V.....
1!~rli~:?QW~Y}
I~;~~~~~~IIII~:I:
i!il~II""",,~~I:llil:i
50V
50V
50V
0.00471LF
20%
100pF
390ILF
5% 500V
20% 400V
CERAMIC
ELECT
CERAMIC
ELECT
ELECT
330pF
220ILF
0.0011LF
220ILF
3300ILF
10%
20%
10%
20%
20%
1-107-896-11
1-126-105-11
1-126-942-61
1-102-116-00
1-136-601-11
ELECT
ELECT
ELECT
CERAMIC
FILM
470ILF
1000ILF
1000ILF
680pF
0.011LF
20% 35V
20% 25V
20% 25V
10% 50V
5%
630V
C940
C941
C942
C943
C944
1-126-934-11
1-126-934-11
1-137-370-11
1-137-370-11
1-104-665-11
ELECT
ELECT
FILM
FILM
ELECT
220ILF
220ILF
0.011LF
0.011LF
100ILF
20%
20%
5%
5%
20%
16V
16V
50V
50V
25V
C621
C622
C623
1-128-564-11
1-136-169-00
1-137-370-11
ELECT
FILM
FILM
220ILF
0.221LF
0.011LF
20%
5%
5%
C624
C625
1-124-903-11
1-102-114-00
ELECT
CERAMIC
1ILF
470pF
100V
50V
50V
(15SF2T)
20% 50V
10% 50V
C945
C946
C948
C949
C951
1-137-370-11
1-102-106-00
1-137-399-11
1-137-399-11
1-136-173-00
FILM
CERAMIC
FILM
FILM
FILM
0.011LF
100pF
0.11LF
0.1jlF
0.471lF
5%
10%
5%
5%
5%
50V
50V
50V
50V
50V
C626
C627
C628
C630
C632
1-137-364-11
1-102-114-00
1-124-927-11
1-126-964-11
1-102-110-00
FILM
CERAMIC
ELECT
ELECT
CERAMIC
0.0011LF
470pF
4.7jlF
10llF
220pF
5%
10%
20%
20%
10%
50V
50V
50V
50V
50V
C952
C953
C954
C960
C961
1-137-372-11
1-137-372-11
1-137-399-11
1-137-374-11
1-102-110-00
FILM
FILM
FILM
FILM
CERAM IC
0.022jlF
O.0221lF
O.1ILF
0.047jlF
220pF
5%
5%
5%
5%
10%
50V
50V
50V
50V
50V
C633
C634
C635
C639
C640
1-137-399-11
1-128-526-11
1-128-528-11
1-137-399-11
1-126-964-11
FILM
ELECT
ELECT
FILM
ELECT
0.11lF
100ILF
470ILF
0.11LF
10ILF
5%
20%
20%
5%
20%
50V
25V
16V
50V
50V
C962
C964
C965
C1801
C1802
1-124-925-11
1-137-364-11
1-136-165-00
1-102-112-00
1-102-112-00
ELECT
FILM
FILM
CERAMIC
CERAMIC
2.21LF
0.0011lF
0.11LF
330pF
330pF
20%
5%
5%
10%
10%
50V
50V
50V
50V
50V
C641
C901
1-137-364-11
1-137-399-11
FILM
FILM
0.0011LF
0.11LF
5%
5%
50V
50V
C607
C608
C609
1-113-912-51
1-101-810-00
1-109-984-11
CERAMIC
CERAMIC
ELECT
C610
C611
C612
C613
C615
1-162-115-00
1-125-700-11
1-162-318-11
1-107-947-11
1-126-944-11
C616
C617
C618
C619
C620
250V
2KV
200V
500V
160V
25V
..g937
.1.:12{):~3!>~
11.. i:LEG.T..
C$.$$&tii~IIA~tt~t1:~!$$1;
C939 1-137-399-11FILM
-33-
5%
0.221lF
50V
5%
50V
0.11LF
....1?.911f'... ...:20o,t~....16V...
4/l:Mt
:'@~#if$QY
5%
0.11LF
50V
CPD-15SF2/15SF2T
n_'
d__"__".....
,............................
:~:~::::::::::::::~::::::~:::::::::::::::::;::~:::::;:::~:::::::::::::::::::::::::::::::::::::::::::::~:::::::::::::::::::::::::::::::::::::::::::::~!~
'.'
'
:~r':':-:':-:':':':':':':':':':-:':':':':':':':':':':':':.;.;.;.;.;.;.;.;.;.;.;.;.;.;.:.:-:.;.:-:.;.;.;.;.;.;.;.:-:-:':':':':-:':':':-:':':':':':':':'j:~::
i1 Les composants
::::
[Q]
r
et une marque
securite.
&
identifies
per un trame
sont critiques pour la
Ne les remplacer
t: t
j iiii
The components
identified
&
and mark
by shading
are critical for safety.
1
ii1i
que par une ,r
!::I:;:,::::~I::::,::~:::~::,::::,:,::~::::::::,~:::::;'::::~::~::::::::;:J!I
!!!!::::::;,:~:~~:::,~~:::,:;:::;:::::;:,:,~,:::::~::::~:::~~::i:~;::::::::::::::::::::::::::::::!:!
REF.NO. PART NO.
REF.NO.
REMARK
DESCRIPTION
CONNECTOR
CN501'1-580-798-11
CN505'1-564-514-11
CN508'1-564-515-11
CN509'1-508-879-00
CN510 1-695-915-11
CONNECTOR
PIN (DY)
PLUG, CONNECTOR
PLUG, CONNECTOR
BA5E P05T
TAB (CONTACT)
6P
11P
12P
.
..............
..Q1NOO~,1&1i~$.1!~?Ht)NWI;'J=:;AP»
CN601 1-691-960-11
CN602 1-695-915-11
CN604'1-691-134-11
CN605'1-506-371-00
PIN,
TAB
PIN,
PIN,
CN606
TAB (CONTACT)
1-695-915-11
/
CONNECTOR
(CONTACT)
CONNECTOR
CONNECTOR
(PC BOARD)
3P
(PC BOARD)
2P
2P
PART
NO.
REMARK
DESCRIPTION
D613
D614
D617
D618
D620
8-719-110-49
8-719-911-19
8-719-109-60
8-719-911-19
8-719-911-19
ZENER
DIODE
ZENER
DIODE
DIODE
DIODE RD18E5B2
155119
DIODE RD2.7E5B2
155119
155119
D621
D901
D902
D904
D907
8-719-911-19
8-719-911-19
8-719-911-19
8-719-109-89
8-719-109-88
DIODE 155119
DIODE 155119
DIODE 155119
ZENER DIODE RD5.6E5B2
ZENER DIODE RD5.6E5B1
D909
D910
D911
D912
D913
8-719-911-19
8-719-911-19
DIODE 155119
DIODE 155119
8-719-911-19
8-719-911-19
DIODE 155119
DIODE 155119
D914
D915
D916
D917
D918
8-719-911-19
8-719-911-19
8-719-911-19
8-719-911-19
8-719-911-19
DIODE
DIODE
DIODE
DIODE
DIODE
D920
D1803
D1804
D1805
D1806
8-719-911-19
8-719-311-90
8-719-311-90
8-719-311-90
8-719-311-90
DIODE 155119
DIODE 5EL1922D-C
DIODE 5EL1922D-C
DIODE5EL1922D-C
DIODE 5EL 1922D-C
D1807
D1808
8-719-311-15
DIODE5EL1422G
8-719-311-90
DIODE
8-719-911-19 DIODE 155119
DIODE
D401
D402
D403
D404
D405
8-719-110-41
8-719-979-58
8-719-908-03
8-719-908-03
8-719-908-03
ZENER
DIODE
DIODE
DIODE
DIODE
DIODE RD15E5B2
EGP10D
GP08D
GP08D
GP08D
P#QiM~&t$81jjj~~?~~NSRP!PP$:BP?lg$~}
D501
D502
D504
D505
8-719-049-12
8-719-979-58
8-719-051-97
8-719-110-17
DIODE
DIODE
DIODE
ZENER
5TUZ52
EGP10D
3DL41A(LC6-15)
DIODE RD10E5B2
D508
D513
8-719-975-77
8-719-970-83
DIODE 5B340
DIODE H5582
~~~itit~~~t~~~i~:ggg~~ij6.P\.
D51iHH8-'i19~109~97
ZENER blOOE
Rb6.8ESB2
D519
D522
D523
D525
D526
8-719-109-97
8-719-911-19
8-719-911-19
8-719-110-31
8-719-018-82
ZENER
DIODE
DIODE
ZENER
DIODE
DIODE RD6.8E5B2
155119
155119
DIODE RD12E5B2
RGP02-20EL-6394
D527
D528
D529
D530
D543
8-719-911-55
8-719-979-60
8-719-911-19
8-719-901-83
8-719-911-19
DIODE
DIODE
DIODE
DIODE
DIODE
U05G
EGP10G
155119
15583
155119
D544
D557
8-719-911-19
8-719-109-81
DIODE 155119
ZENER DIODE RD4.7E5B2
155119
155119
155119
155119
155119
5EL 1922D-C
FU5E
..
f@f;$.18$?W~jM1fU$$(8;~;o.ifi4Ai?'~QYI
FERRITE
~~~~II~~~[i~~~~~I:II~~I~~~r
D598
8-719-110-41
ZENER
FB501
FB502
FB601
FB602
FB603
1-410-396-41
1-410-396-41
1-535-303-00
1-410-396-41
1-410-396-41
FERRITE BEAD
FERRITE BEAD
LEAD, JUMPER
FERRITE BEAD
FERRITE BEAD
INDUCTOR
INDUCTOR
(5.0MM)
INDUCTOR
INDUCTOR
0.45j.lH
0.45j.lH
FB604
FB605
FB606
FB607
FB901
1-410-396-41
1-410-396-41
1-535-303-00
1-535-303-00
1-410-397-21
FERRITE BEAD
FERRITE BEAD
LEAD, JUMPER
LEAD, JUMPER
FERRITE BEAD
INDUCTOR
INDUCTOR
(5.0MM)
(5.0MM)
INDUCTOR
0.45j.lH
0.45j.lH
FB902 1-410-397-21
DIODE RD15E5B2
D599
8-719-911-19
DIODE 155119
Js
PM1...~fn~iq~~1i!!!!P!QPI;&~!J@k@1i!~)
'
"
" "..................................................................................
"
D602
8-719-908-03
DIODE GP08D
D604
8-719-908-03
DIODE GP08D
D605
8-719-048-62
DIODE UF3ML-6505
..."
D607
D608
D609
D610
D611
8-719-054-51
8-719-979-50
8-719-051-97
8-719-053-19
8-719-300-76
DIODE
DIODE
DIODE
DIODE
DIODE
BEAD
FERRITE
BEAD INDUCTOR
TERMINAL
GT002'1-537-738-21
TERMINAL,
EARTH
IC
D8LC20U-4012
EGP30D
3DL41A(LC6-15)
UF40Q7G23
RH-1A
... .IQ400.
.8~ 7Ei9~803:4,2IQ
.LA6500:F
to...
)1~~III~~~I~liJ.~~I~~lli~~~~
IC502 8-759-054-26 IC HD74HC123AP
-34-
0.45j.lH
0.45j.lH
1.1j.lH
1.1 ~LH
CPD-15SF2/15SF2T
:~)~:::::;;;~:.-:::~:~~:~~:~~:~~:::::~:.~~~:::~:::::::::::~::::::~:~::::~::~::::::~:~:~:::::::::::~::::::~:::::::::r:::::~~::::~~~~~:
The components
identified by shading
.~~ and mark .&. are critical for safety.
Replace only with part number specified.
m
~~~r::~::::::~::::::::::::::~::::::~::~::~::~::~:~~::r:::::::~:::::::::~::~::~::~::~::~::::::::::::~:~::::::::::::::::~:::::::::~~~~
~:@
~~jj~
~j~~~
Les composants
:I et une
~r
identifies
marque.&.
per un trame
sont critiques
:~j~~
pour la
:~m
securite. Ne les remplacer que par une
~r
[Q]
!:!::
:m
::*'~~:~:::::::::::~~::::;;%::::~::~:::::::::;::::::::~:::::~::::::~::~::::::::~::~::~::::::~:::::::~:::::~::::::::::~:::::~::::::::::::
1II!;:;i~:::~:::;:~;~:::::;:;::;::~:~::::~;':~:~:::~~:;,:::::~:,::::::;:::~:JIII
REF.NO.
PART NO.
DESCRIPTION
REMARK
REF.NO.
PART NO.
DESCRIPTION
REMARK
IC504
8-759-980-58
IC TDA8172
0603
8-729-119-78
TRANSISTOR
2SC2785-HFE
IC601
IC602
IC901
IC902
IC903
8-759-335-24
8-759-335-23
8-759-354-66
8-759-921-08
8-759-165-81
IC TEA2262
IC TDA8138
ST7271N5B1/CCM
IC SN74HC02AN
IC PST600D-T
0604
0605
0606
0900
0901
8-729-119-76
8-729-141-83
8-729-119-78
8-729-119-78
8-729-119-76
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANS ISTOR
TRANSISTOR
2SA 1175-HFE
2SB1094-LK
2SC2785-HFE
2SC2785-HFE
2SA 1175-HFE
IC904
IC905
IC908
8-759-336-24
8-759-000-49
8-759-503-91
IC TDA9103
IC MC14066BCP
IC TL082ACP
0902
0903
0904
0907
8-729-119-78
8-729-900-36
8-729-119-78
8-729-119-78
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC2785-HFE
DTC124ES
2SC2785-HFE
2SC2785-HFE
COIL
RESISTOR
L501
L502
L504
L505
L506
1-412-550-11
1-412-537-31
1-459-104-00
1-412-531-31
1-459-104-00
INDUCTOR
1.2MMH
INDUCTOR
100~H
COIL, WITH CORE
INDUCTOR
33~H
COIL, WITH CORE
L507
L513
L601
L606
L608
1-412-531-31
1-409-803-11
1-412-537-31
1-412-537-31
1-406-665-11
INDUCTOR
33~H
COIL, HORIZONTAL
LINEARITY
INDUCTOR
100~H
INDUCTOR
100~H
COIL, CHOKE 100UH
L900
L901
L902
L903
1-412-537-31
1-412-537-31
1-412-537-31
1-412-537-31
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
100~H
100~H
100~H
100~H
R002
R003
R004
R005
R006
1-247-807-31
1-247-807-31
1-249-417-11
1-249-417-11
1-249-417-11
CARBON
CARBON
CARBON
CARBON
CARBON
100
100
1K
1K
1K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R007
R008
R072
R401
R402
1-249-417-11
1-249-417-11
1-215-445-00
1-215-443-00
1-249-429-11
CARBON
CARBON
METAL
METAL
CARBON
1K
1K
10K
8.2K
10K
5%
5%
1%
1%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R403
R404
R405
R406
R407
1-249-439-11
1-215-485-00
1-249-401-11
1-215-447-00
1-215-449-00
CARBON
METAL
CARBON
METAL
METAL
68K
470K
47
12K
15K
5%
1%
5%
1%
1%
1/4W
1/4W
1/4W
1/4W
1/4W
R408
R409
R410
R411
R412
1-249-383-11
1-215-429-00
1-215-883-11
1-215-460-00
1-215-439-00
CARBON
METAL
METAL OXIDE
METAL
METAL
1.5
2.2K
33
43K
5.6K
5%
1%
5%
1%
1%
1/4W
1/4W
2W
1/4W
1/4W
R415
R416
R417
R418
R419
1-249-419-11
1-249-441-11
1-215-427-00
1-216-391-11
1-247-887-00
CARBON
CARBON
METAL
METAL OXIDE
CARBON
1.5K
100K
1.8K
1.5
220K
5%
5%
1%
5%
5%
1/4W
1/4W
1/4W
3W
1/4W
R420
R421
R422
R423
R424
1-247-889-00
1-202-963-11
1-215-866-11
1-215-439-00
1-215-447-00
CARBON
METAL
METAL OXIDE
METAL
METAL
270K
1
330
5.6K
12K
5%
1%
5%
1%
1%
1/4W
1W
1W
1/4W
1/4W
R425
R426
R427
R428
R429
1-215-439-00
1-249-383-11
1-215-447-00
1-249-421-11
1-249-417-11
METAL
CARBON
METAL
CARBON
CARBON
5.6K
1.5
12K
2.2K
1K
1%
5%
1%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R436
R440
R441
R444
R445
1-216-392-11
1-249-428-11
1-249-405-11
1-247-863-91
1-215-888-00
METAL OXIDE
CARBON
CARBON
CARBON
METAL OXIDE
1.8
8.2K
100
22K
220
5%
5%
5%
5%
5%
3W
1/4W
1/4W
1/4W
2W
FILTER
ttm~MM@;~i"77@j@t0;N$FQRMe.fWMM!ffWtefft:.:..::......
IC LINK
::~:p$.i~hA&M&~:!F00ij4j:MNK;jQ::~QijMN$QVt
TRANSISTOR
0401
0402
0403
0501
0502
8-729-031-89
8-729-119-78
8-729-119-76
8-729-119-76
8-729-931-45
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC3941A-0(TA}
2SC2785-HFE
2SA 1175-HFE
2SA1175-HFE
IRF614
0503
0507
0510
0512
0513
8-729-027-97
8-729-027-95
8-729-027-82
8-729-027-96
8-729-027-96
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
IRFI9630G-LF
2SC5129(LBSONY}
IRFPE40LF20
IRLl530G
IRLl530G
0514
0517
0520
0522
0524
8-729-027-96
8-729-119-76
8-729-900-36
8-729-143-79
8-729-119-78
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
IRLl530G
2SA1175-HFE
DTC124ES
2SK738
2SC2785-HFE
0525
0526
0601
0602
8-729-119-78
8-729-119-76
8-729-142-46
8-729-926-52
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC2785-HFE
2SA1175-HFE
2SC2001-LK
IRFPC40
.............
F
F
F
F
F
F
F
F
mm:B4Sa~~iati1~5~1$3~ijij[~~MsAtf[m[mt}~~mJrIa6K~[rfmm~~m:r[a~Arf~~Ijt.4Yfk~~r:?
R451
R452
-35-
1-216-474-11
1-249-428-11
METAL OXIDE
CARBON
82
8.2K
5%
5%
3W
1/4W
F
CPD-15SF2/15SF2T
~
:~t:~:::::::::::::~::::,;;;:::::,:;;j;;:::;::,::*:~~~~::~::::::~::~::~::::::::::::::*;:::::i::::::::~::~::::::$~~~~:::;?.Q.-:::1~
~~.t::;::::::x:::~*::=;~::::::;~:::§::::::::;-:-~~:*::-~::-.:::::::::~::::::::::-.;~~:;-:::-~::::::.~~:::::::::::'=::~:::}-:::~$j;
l
t
Les composants
identifies per un trame ji!
et une marque &. sont critiques pour la @
:i:!
securite.
t
Ne les remplacer
R455
1-216-393-00 METAL OXIDE 2.2
1-219-683-11
METAL
.
220K
f!4.5.8... .1:24!}:3.!:!7.: 1..1..GJ\FlB()t-J...
...?2.......
~lIlj~~~~II~~~I~I~
i~:~1
.. .FI.4 7.4
~:~15.:493:()q
,',',)h7,',',\"""
M.E:I Ak..
J3'4(~4:iJS~1$.84~n~~M~*M>
R480 1-249-397-11 CARBON
5%
3W
5%
1/2W
F
5%
3W
1~/~Mf1iWtL
5%
1/4W
R4$7*jHM$#t~t$iMIt.M:?ijQKm
B47~mj~g4W@~M:[email protected]
R473 1-215-469-00 METAL
REF.NO.
REMARK
DESCRIPTION
1-216-474-11 METAL OXIDE 82
F
F
jWJ:W4wt
1%:
."."
9 m
I .,..4.~r\F
100K
H1tv1H.
lwm
22
a.1
. ... ....... ...
H
&.
H.
.. . HH....."
.""S m A t
4 ..."J'
7 2 OO.""
M
/..'.«,'.,)
.................
...H...H.
H. ......
1'..>
30 K
.,.I
,~im~~~~$8if~~:~i~~r~!g;'%~~K%
R4$!mMjn$M~t~~~:MirAk
')$~i.())
R497 1-249-417-11CARBON
1K
"
:t
'iii'
1/4W
~~:~I.4.W\
5%
.
.
...
........
B4W3 m..k?tgf@HPQM!;[~P\
"
""....................................................................
R499
1-249-377-11 CARBON
R502
1-249-417-11 CARBON
R503
1-249-437-11 CARBON
R504
1-249-437-11 CARBON
5%
1/4W
5%
1/4W
9"!9 1!4"Y
$%!::M4.WI:
5%
1/4W F
j%#4:wY
:~~jiw::f
tW¥j:V4W!'\
5% 1/4W F
REMARK
1-216-427-00
METAL OXIDE
120
5%
1W
R570
R571
R572
R573
R574
1-215-441-00
1-249-377-11
1-249-426-11
1-249-429-11
1-249-429-11
METAL
CARBON
CARBON
CARBON
CARBON
6.8K
0.47
5.6K
10K
10K
1%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
...
...........
1/4W F
1/4W F
1/4W
1/4W
.1::21. !5:¥!:I:q().~.
~I J\.L....
R$.JtWH~~mMt~$l\$qUQj"
R602
1-202-933-61 FUSIBLE
R603
1-215-469-00 METAL
R604
1-211-874-11 FUSIBLE
R605
R606
R607
R608
R609
5.6K
5%
4.7K
H..!:i,,!0
:::jZKIt:II$.o/~m:n4w.tj
5.6K
5%
5.6K
5%
F
F
1/4W
1!4W...
1/4W
1/4W
1-219-154-11
1-219-154-11
1-216-345-11
1-249-417-11
1-249-417-11
FUSIBLE
FUSIBLE
METAL OXIDE
CARBON
CARBON
15K
1%
1/4W
ii$~$/{tiQ%tNl?wt
0.1
100K
0.12
10%
1%
.10%
1/2W
1/4W
1/2W
0.12
0.12
0.47
1K
1K
10%
10%
5%
5%
5%
1/4W
1/4W
1W
1/4W
1/4W
F
F
5%
1/4W
5%
1/4W
10% 1/4W
R617
...1;.0/.0.~W
r=.
,:~iiM~~~:j$ii~~j:Mgif~~:~xli$.:t~~K:::m:mt {:?%:):rwm::}r'
R610
1-249-437-11
1-249-408-11
1-219-154-11
CARBON
CARBON
FUSIBLE
47K
180
0.12
R622
R623
R624
R625
R626
1-211-874-11
1-249-436-11
1-249-394-11
1-249-393-11
1-249-429-11
FUSIBLE
CARBON
CARBON
CARBON
CARBON
0.12
39K
12
10
10K
10%
5%
5%
5%
5%
R627
1-249-405-11
CARBON
100
5%
.............................
.. ..........................
...... .. . .......
." 1%H"H" 1 [;4. W
R611
'
::::::::..::::.:~:~:::~:::~:::..::.::...::..::..}::::~::::::
5%
5%
5%
5%
DESCRIPTION
1/4W F
..
4z@!l
0.47
1K
47K
47K
NO.
R575
1-249-426-11 CARBON
....13.fj7.~ .1.:~4~:.4?!:i:1 J .9ARElQI'-J..
:~$ltmWg4QgWtdlPA8~PNm
R582
1-249-426-11 CARBON
R583
1-249-426-11 CARBON
1
1%
PART
R569
... R589...
..
."
ill!
Mf1iWt
.................................
.........
'iii'iM''''''.''''
."
';;Oi'''
}t~~t~~~~~:~:::~:::::. :r:~j~t:~~:f:::i
R481
1-249-419-11 CARBON
1.5K
R484
1-249-435-11 CARBON
3.3K
..R485... .1:?49:421.: 11..GARBgt-J .?,?IS
8mW*M?4~@?W:nqAB~Q~::!:::::::)A~W:
R490 1-249-417-11 CARBON
1K
.
by shading
iiiii:,:,::::~::::~:,:~~:~,~,:::::,:,:,~:::,::~,~:~~:::,::~:~~~~::~;~~I
R453
R454
..
par une
identified
lii!",,:~::::~:,:,~~:::::::::,:::::::::~,:::::~:,:~::~~::::::,;,:~:~:~:~:~:,:«~Ii
REF.NO. PART NO.
."".8
que
The components
t: and mark &. are critical for safety.
1/2W
1/4W
1/4W
1/4W
1/4W
R505 1-215-427-00 METAL
1.8K
1%
R506 1-247-883-00 CARBON
150K
5%
Rq07... .1::24~:437: 1t. GN~BQN
4?!$
5"(0
R$Q~*Mgj$.M§WQQM§t.M:td:mm~w.~I::I:::)%:tM~W!t,
B$Q~M':imM$.#.Wtf~QMJ;\TAW:':::gg:":dW~:j:at.4WI:
1/4W
1/4W
.1j4W....
R5.11H1:~4?:88?:()OHCARElQI'-JH HHHH22()~H
5%
1/4W
f!$1~m%~4~#$~@WCAR!;!!QNm:jj:::~Wj5f4a!~Wt
R516 1-215-447-00 METAL
12K
1%
R517 1-215-489-00METAL
680K
1%
R518 1-215-475-00 METAL
180K
1%
1/4W
1/4W
1/4W
R628
R629
R630
R631
1-215-463-00
1-215-421-00
1-207-983-00
1-249-441-11
METAL
METAL
WIREWOUND
CARBON
56K
1K
0.18
100K
1/4W
(15SF2T)
1%
1/4W
1%
1/4W
10% 3W
F
5%
1/4W
R519
R520
R521
R524
R525
1-249-437-11
1-215-443-00
1-215-867-00
1-216-447-00
1-215-461-00
CARBON
METAL
METAL OXIDE
METAL OXIDE
METAL
47K
8.2K
470
27
47K
5%
1%
5%
5%
1%
1/4W
1/4W
1W
2W
1/4W
R632
R633
R634
R635
R636
1-247-863-91
1-249-429-11
1-215-433-00
1-215-419-00
1-247-791-91
CARBON
CARBON
METAL
METAL
CARBON
22K
10K
3.3K
820
22
5%
5%
1%
1%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R526
R527
R528
R529
R530
1-215-465-00
1-215-459-00
1-215-445-00
1-249-415-11
1-249-931-11
METAL
METAL
METAL
CARBON
CARBON
68K
39K
10K
680
2.2K
1%
1%
1%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R637
R638
R639
R640
R641
1-249-417-11
1-215-421-00
1-215-397-00
1-215-397-00
1-249-415-11
CARBON
METAL
METAL
METAL
CARBON
1K
1K
100
100
680
5%
1%
1%
1%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R531
R532
R535
R563
R564
1-249-432-11
1-249-429-11
1-249-429-11
1-249-441-11
1-249-421-11
CARBON
CARBON
CARBON
CARBON
CARBON
18K
10K
10K
100K
2.2K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R642
R645
R646
R647
R648
1-247-863-91
1-249-427-11
1-215-463-00
1-215-435-00
1-249-393-11
CARBON
CARBON
METAL
METAL
CARBON
22K
6.8K
56K
3.9K
10
5%
5%
1%
1%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R565
R566
R567
R568
1-215-441-00
1-215-912-11
1-215-907-11
1-215-859-00
6.8K
METAL
METAL OXIDE 150
METAL OXIDE 22
METAL OXIDE 22
1%
5%
5%
5%
1/4W
3W
3W
1W
R649
R650
R651
R652
1-247-891-00
1-215-445-00
1-215-449-00
1-249-429-11
CARBON
METAL
METAL
CARBON
330K
10K
15K
10K
5%
1%
1%
5%
1/4W
1/4W
1/4W
1/4W
F
F
F
F
F
F
-36-
F
F
CPD-155F2/155F2T
~*»::i-~»=:«.;.m
The components identified by shading
and mark & are criticalfor safety.
k
ill
11i
Replace only with part number specified. m
:~*~:~:::~::~::::~:~::::::::~::::::::::::::;~::::::::"::::::::::::~::::::::"::~:::::::::::::;~~::::~:}:::::::::~*::%:::::::~:»:i~~~:
-
W&~»;::*'::::"-'
-..""'
i
Les composants identifies per un trame
et une marque it sont critiques pour la
:fi securite. Ne les remplacer que par une
i
;w
pieceportant Ie numerospecifie.
[Q]
.
~~:-:::::~:::::;":"::~:::::.~:.:::~:*::::::::-~:":::::.::~w?~w::t.;-:-.:::::*:-.::?«.:*?.;-:-';~=:':::'::::::*::::::::::;":-::'"
REF.NO. PART NO.
R656
1-249-403-11 CARBON
REF.NO. PART NO.
REMARK
DESCRIPTION
68
R657 1-249-417-11 CARBON
1K
R658 1-249-417-11 CARBON
1K
::RmsJMi!'H2Q$.~mm~g1tW!R~QN(t\%MW:
R900 1-249-417-11 CARBON
1K
R901 1-249-425-11 CARBON
4.7K
5%
1/4W
5%
1/4W
5%
1/4W
................................
...,..,.,.,.,.
n...
n...
n
'-'.'."'.'
O
"''' OW
~ ."""""-"'.'
:4.
:::::::?::"":'",:::::::::::::.:,...:.::.:,.::::::::::
'
"'
5%
5%
1/4W
1/4W
R902
R903
R904
R905
R907
1-249-425-11
1-249-425-11
1-249-425-11
1-215-471-00
1-249-417-11
CARBON
CARBON
CARBON
METAL
CARBON
4.7K
4.7K
4.7K
120K
1K
5%
5%
5%
1%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R908
R910
R912
R913
R914
1-247-863-91
1-249-437-11
1-215-477-00
1-247-863-91
1-247-863-91
CARBON
CARBON
METAL
CARBON
CARBON
22K
47K
220K
22K
22K
5%
5%
1%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R915
R916
R918
R919
R920
1-249-417-11
1-249-417-11
1-249-435-11
1-249-425-11
1-249-417-11
CARBON
CARBON
CARBON
CARBON
CARBON
1K
1K
33K
4.7K
1K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R921
R923
R924
R925
R926
1-247-863-91
1-249-425-11
1-249-432-11
1-215-451-00
1-249-434-11
CARBON
CARBON
CARBON
METAL
CARBON
22K
4.7K
18K
18K
27K
5%
5%
5%
1%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R927
R928
R929
R930
R931
1-249-434-11
1-249-434-11
1-249-436-11
1-247-881-00
1-249-428-11
CARBON
CARBON
CARBON
CARBON
CARBON
27K
27K
39K
120K
8.2K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R932
R933
R934
R935
R936
1-249-428-11
1-215-445-00
1-249-428-11
1-249-428-11
1-249-393-11
CARBON
METAL
CARBON
CARBON
CARBON
8.2K
10K
8.2K
8.2K
10
5%
1%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R937
R938
R939
R940
R941
1-249-428-11
1-249-425-11
1-249-417-11
1-215-409-00
1-249-434-11
CARBON
CARBON
CARBON
METAL
CARBON
8.2K
4.7K
1K
330
27K
5%
5%
5%
1%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R944
R945
R946
R947
R948
1-249-424-11
1-249-424-11
1-247-903-00
1-249-439-11
1-247-903-00
CARBON
CARBON
CARBON
CARBON
CARBON
3.9K
3.9K
1M
68K
1M
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R949
R950
R951
R952
R953
1-247-883-00
1-247-883-00
1-247-883-00
1-247-883-00
1-249-425-11
CARBON
CARBON
CARBON
CARBON
CARBON
150K
150K
150K
150K
4.7K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R954
R955
R956
R957
R958
1-249-425-11
1-249-436-11
1-249-421-11
1-247-852-11
1-249-420-11
CARBON
CARBON
CARBON
CARBON
CARBON
4.7K
39K
2.2K
7.5K
1.8K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R959
R960
R961
R962
R963
1-215-409-00
1-249-429-11
1-215-459-00
1-249-417-11
1-249-441-11
METAL
CARBON
METAL
CARBON
CARBON
R965
R966
R967
1-249-417-11 CARBON
1-249-441-11 CARBON
1-249-425-11 CARBON
::::\:;tb\:W,j8~m~i#,j:jm~A;~N:::m
-37-
REMARK
DESCRIPTION
330
10K
39K
1K
100K
1%
5%
1%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
1K
5%
1/4W
100K
5%
1/4W
4.7K
5%
1/4W
22K
~"(o J!41J11.....
::mlKt::t'::::::tN~%i.ttal"Wfi:
R972
R974
R975
R976
R977
1-249-429-11
1-249-393-11
1-249-421-11
1-249-429-11
1-249-417-11
CARBON
CARBON
CARBON
CARBON
CARBON
10K
10
2.2K
10K
1K
5%
5%
5%
5%
5%
1/4W
1/4W F
1/4W
1/4W
1/4W
R979
R980
R981
R984
R985
1-249-417-11
1-249-417-11
1-247-903-00
1-247-895-91
1-249-427-11
CARBON
CARBON
CARBON
CARBON
CARBON
1K
1K
1M
470K
6.8K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R989
R990
R991
R992
R993
1-247-887-00
1-249-417-11
1-247-895-91
1-247-895-91
1-249-417-11
CARBON
CARBON
CARBON
CARBON
CARBON
220K
1K
470K
470K
1K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R994
R997
R998
R999
R1000
1-249-431-11
1-249-414-11
1-247-895-91
1-249-429-11
1-249-440-11
CARBON
CARBON
CARBON
CARBON
CARBON
15K
560
470K
10K
82K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R1001
R1002
R1801
R1803
R1804
1-249-429-11
1-249-417-11
1-215-433-00
1-249-413-11
1-249-413-11
CARBON
CARBON
METAL
CARBON
CARBON
10K
1K
3.3K
470
470
5%
5%
1%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R1805
R1806
R1807
R1808
R1809
1-249-413-11
1-215-421-00
1-249-413-11
1-249-413-11
1-249-413-11
CARBON
METAL
CARBON
CARBON
CARBON
470
1K
470
470
470
5%
1%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R1810
R1811
R1812
R1813
R1814
1-215-413-00
1-215-409-00
1-215-413-00
1-215-413-00
1-215-417-00
METAL
METAL
METAL
METAL
METAL
470
330
470
470
680
1%
1%
1%
1%
1%
1/4W
1/4W
1/4W
1/4W
1/4W
R1815 1-215-469-00
R1817 1-249-413-11
R1818 1-215-425-00
R1819 1-215-425-00
R1820 1-215-433-00
METAL
CARBON
METAL
METAL
METAL
100K
470
1.5K
1.5K
3.3K
1%
5%
1%
1%
1%
1/4W
1/4W
1/4W
1/4W
1/4W
R1821
R1822
R1823
R1832
CARBON
METAL
METAL
METAL
470
3.3K
470
100K
5%
1%
1%
1%
1/4W
1/4W
1/4W
1/4W
1-249-413-11
1-215-433-00
1-215-413-00
1-215-469-00
CPD-15SF2/15SF2T
B
The components
identified
by
in this
manual
have been carefully
factoryselected
for eachset
in order to satisfy
regulations
regarding
X-ray radiation,
Should replacement
be required,
replace
only with the value originally
used.
[Q]
rffl'Z;"'J:;'w:'W';w..w.==-<-w=~.::.",,".if*%
The components
id~?Iified by shading
f. and mark .&. are cntlcal for safety.
i
les composants
identifies
per un trame
et une marque.&.
sont critiques
pour la
securite.
Ne les rem placer que par une
'.'.
piece portant
Ie numero
specifie.
,:.:.;
t
if
Replace
only
with
part
number
specified.
f:1
~::«:;:::::::::::::::=;:.«--:-.r-::::::.w»:m-::.:::;-:-«:::;.-::::*"*--:::::-==*w.::::::-:;:::::.*.::::«t~~
~1.:::$::::.:::~*:;::::---:::::.::::"=*:::::r&..*::.-::;w,;~~::::~~
REF.NO.
PART NO.
VARIABLE
DESCRIPTION
REMARK
REF.NO. PART NO.
RESISTOR
DESCRIPTION
REMARK
THERMISTOR
~RV4tQ~~~~~!~~~t!~1~5!g~~~~TD!~'~~8r6::~~e~:~~~;;~fmf:~;~f::~::;;:;t&j;iti~i_j;t~1tiG;f_ij~;;!~f:;;::;!;:;ff~~;r:;r:!;~~:rrJ::;;~~~;;;~;;f::;;:~f:r;:~f;~:~:;~~~~
RV601
1-241-764-11
RES, ADJ, CERMET
10K
THERMISTOR
RELAY
.~ftt.a.mm~mb~Q.mmWnlitt.flgijM$tQij;:!:PQ$ttj~ffffff!Jf:J;fJJJ~:
;:ffl¥§Q1jt~$.jfu~iQa?fliP.\¥:!?\:~:{/JJmf!ff:fmJ:J;~J;!({?f:~;f!ff;ff!f;
VARISTOR
SWITCH
S500
S501
S1801
S1802
S1803
1-572-707-11
1-553-809-21
1-762-093-11
1-762-093-11
1-762-093-11
SWITCH,
SWITCH,
SWITCH,
SWITCH,
SWITCH,
LEVER
SLIDE
TACTILE
TACTILE
TACTILE
S1815
S1816
S1817
S1818
S1819
1-692-220-11
1-692-220-11
1-692-220-11
1-692-220-11
1-692-431-21
SWITCH,
SWITCH,
SWITCH,
SWITCH,
SWITCH,
TACTILE
TACTILE
TACTILE
TACTILE
TACTILE
S1821
1-692-220-11
SPARK
SG501
SWITCH,
;:f?i'AMj:~ja:t$.fg~$.jJ;QgijAMj;rJ:f:::;::;JQ;QQjimf;J~!:$!M.(:!;::_vWJJ;:;
CRISTAL
X900
GAP,
MISCELLANEOUS
TACTILE
SPARK
'
;~:'r:r':~::;)~"tN*;M$ijlMtSri';'?rr:;:':":::;:::::':::':::
TRANSFORMER,
TRANSFORMER,
FERRITE
FERRITE
",.
(DFT)
(HOT)
;;~id.i~:i:;j.~~~~*~~i~j:j;'t_~Mi~:iiMitg~k~Rn;::;;:r
T603
1-429-118-11
TRANSFORMER,
FERRITE
(PST)
Sony
9-978-492-01
-
::!!;::!;:'lllli;II:lllijj!il!I!~~II~.~j;j::ir.IIII.IIr.11.11''-I.!~II~J.~jll!:'!.!'I..111
1-540-005-21
CAP ASSY, HIGH VOLTAGE
1-765-717-11
CORD SET, POWER
(except for US/CND)
1-765-718-11
CORD SET, POWER
(US/CND)
:;J.§P'j;~~*~MiM.f:1;[email protected]~!!$YMQW::~:::;i
1-429-109-11
1-429-103-11
CRYSTAL
**********************
TRANSFORMER
T503
T504
VIBRATOR,
********11'**********************************************************************
GAP
1-519-422-11
1-567-890-11
Corporation
Consumer A&V Products Company
TV&Display
Products Div.
-38-
~
~
English
95HL05147-1
Printed in Japan
@ 1995.8
Related documents
SERVICE MANUAL
SERVICE MANUAL
TB-6S-LX150T-IMG2 Hardware User Manual
TB-6S-LX150T-IMG2 Hardware User Manual
Sony CPD-15SF2 User's Manual
Sony CPD-15SF2 User's Manual
TB-7K-325T-IMG Hardware User Manual
TB-7K-325T-IMG Hardware User Manual
Multiscan15sfII Multiscan17sfII
Multiscan15sfII Multiscan17sfII
Sony KE-50XBR900 User's Manual
Sony KE-50XBR900 User's Manual
TTP-243 Plus
TTP-243 Plus
Cisco Catalyst Express 500 User guide
Cisco Catalyst Express 500 User guide
Multiscan15sf II Multiscan17sf II
Multiscan15sf II Multiscan17sf II
1. A-700T Front pages
1. A-700T Front pages
SONY CPD-200ES chassis X2F2015-05
SONY CPD-200ES chassis X2F2015-05