Download Sony CDX-C5005 CD Player

CDX-C5000X/C5005/C6800X
SERVICE MANUAL
US Model
Canadian Model
Ver 1.1 2000. 08
CDX-C5000X/C5005
E Model
CDX-C6800X
Photo: CDX-C5000X
• The tuner and CD sections have no adjustments.
SPECIFICATIONS
AUDIO POWER SPECIFICATIONS (US Model)
POWER OUTPUT AND TOTAL HARMONIC DISTORTION
19 watts per channel minimum continuous average power into
4 ohms, 4 channels driven from 20 Hz to 20 kHz with no more
than 1% total harmonic distortion.
Model Name Using Similar Mechanism
NEW
CD Drive Mechanism Type
MG-383Z-121//K
Optical Pick-up Name
KSS-720A
Harmonic distortion at 1 kHz
0.6% (stereo),
0.3% (mono)
Separation
35 dB at 1 kHz
Frequency response
30 – 15,000 Hz
AM
Other Specifications
CD player section
Compact disc digital audio
system
Signal-to-noise ratio
90 dB
Frequency response
10 – 20,000 Hz
Wow and flutter
Below measurable limit
Laser Diode Properties (CDX-C5000X/C5005)
Material
GaAlAs
Wavelength
780 nm
Emission Duration
Continuous
Laser output power
Less than 44.6 µW*
* This output is the value measured at a distance
of 200 mm from the objective lens surface on the
Optical Pick-up Block.
Tuning range
System
CDX-C5000X/C5005:
530 – 1,710 kHz
CDX-C6800X:
AM tuning interval:
9 kHz/10 kHz
switchable
531 – 1,602 kHz
(at 9 kHz step)
530 – 1,710 kHz
(at 10 kHz step)
Power amplifier section
Outputs
Speaker outputs
(sure seal connectors)
Speaker impedance
4 – 8 ohms
Maximum power output 50 W × 4 (at 4 ohms)
Tuner section
FM
Tuning range
CDX-C5000X/C5005:
87.5 – 107.9 MHz
CDX-C6800X:
FM tuning interval:
50 kHz/200 kHz
switchable
87.5 – 108 MHz
(at 50 kHz step)
87.5 – 107.9 MHz
(at 200 kHz step)
Antenna terminal
External antenna connector
Intermediate frequency 10.7 MHz/450 kHz
Usable sensitivity
8 dBf
Selectivity
75 dB at 400 kHz
Signal-to-noise ratio
66 dB (stereo),
72 dB (mono)
– Continued on next page –
FM/AM COMPACT DISC PLAYER
MICROFILM
1
Ver 1.1 2000. 08
General
Outputs
Tone controls
Power requirements
Dimensions
Mounting dimensions
Mass
Supplied accessories
TABLE OF CONTENTS
Audio outputs
Power antenna relay
control lead
Power amplifier control
lead
Telephone ATT control
lead
Bass ±9 dB at 100 Hz
Treble ±9 dB at 10 kHz
12 V DC car battery
(negative ground)
Approx. 178 × 50 × 183 mm
(7 1/8 × 2 × 7 1/4 in.)
(w/h/d)
Approx. 182 × 53 × 162 mm
(7 1/4 × 2 1/8 × 6 1/2 in.)
(w/h/d)
Approx. 1.2 kg (2 lb. 10 oz.)
Parts for installation and
connections (1 set)
Front panel case (1)
Design and specifications are subject to change without
notice.
SERVICE NOTES
CAUTION
Use of controls or adjustments or performance of procedures
other than those specified herein may result in hazardous
radiation exposure.
If the optical pick-up block is defective, please replace the whole
optical pick-up block.
Never turn the semi-fixed resistor located at the side of optical
pick-up block.
optical pick-up block
1. GENERAL
Location of controls ................................................................. 3
Getting Started ......................................................................... 3
Setting the clock ...................................................................... 3
CD Player CD/MD Unit (optional) ......................................... 4
Radio ....................................................................................... 5
Other Functions ....................................................................... 6
TV/Video (optional) ................................................................ 7
Connections ............................................................................. 8
2. DISASSEMBLY
2-1. Sub Panel (CD) Assy ......................................................... 10
2-2. CD Mechanism Block ....................................................... 10
2-3. Main Board ....................................................................... 11
2-4. Heat Sink ........................................................................... 11
2-5. Chassis (T) Sub Assy ........................................................ 12
2-6. Lever Section ..................................................................... 12
2-7. Servo Board ....................................................................... 13
2-8. Shaft Roller Assy .............................................................. 13
2-9. Floating Block Assy .......................................................... 14
2-10. Optical Pick-up Block ....................................................... 14
3. DIAGRAMS
3-1. IC Pin Descriptions ........................................................... 15
3-2. Block Diagram –CD Section– ........................................... 21
3-3. Block Diagram –Tuner Section– ....................................... 22
3-4. Block Diagram –Display Section– .................................... 23
3-5. Circuit Boards Location .................................................... 23
3-6. Printed Wiring Boards –CD Mechanism Section– ............ 24
3-7. Schematic Diagram –CD Mechanism Section (1/2)– ....... 26
3-8. Schematic Diagram –CD Mechanism Section (2/2)– ....... 27
3-9. Schematic Diagram –Main Section (1/2)– ........................ 28
3-10. Schematic Diagram –Main Section (2/2)– ........................ 29
3-11. Printed Wiring Board –Main Section– .............................. 30
3-12. Printed Wiring Board –Relay Section– ............................. 31
3-13. Schematic Diagram –Relay Section– ................................ 32
3-14. Schematic Diagram –Display Section– ............................. 33
3-15. Printed Wiring Board –Display Section– .......................... 34
3-16. IC Block Diagrams ............................................................ 35
4. EXPLODED VIEWS
semi-fixed resistor
NOTES ON HANDLING THE OPTICAL PICK-UP BLOCK
OR BASE UNIT
The laser diode in the optical pick-up block may suffer electrostatic
breakdown because of the potential difference generated by the
charged electrostatic load, etc. on clothing and the human body.
During repair, pay attention to electrostatic breakdown and also use
the procedure in the printed matter which is included in the repair
parts.
The flexible board is easily damaged and should be handled with
care.
NOTES ON LASER DIODE EMISSION CHECK
The laser beam on this model is concentrated so as to be focused on
the disc reflective surface by the objective lens in the optical pickup block. Therefore, when checking the laser diode emission, observe from more than 30 cm away from the objective lens.
Notes on Chip Component Replacement
• Never reuse a disconnected chip component.
• Notice that the minus side of a tantalum capacitor may be damaged by heat.
2
4-1.
4-2.
4-3.
4-4.
4-5.
Chassis Section ................................................................. 38
Front Panel Section ........................................................... 39
CD Mechanism Section (1) ............................................... 40
CD Mechanism Section (2) ............................................... 41
CD Mechanism Section (3) ............................................... 42
5. ELECTRICAL PARTS LIST ........................................ 43
SAFETY-RELATED COMPONENT WARNING!!
COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE
WITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN
THE PARTS LIST ARE CRITICAL TO SAFE OPERATION.
REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE
PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR
IN SUPPLEMENTS PUBLISHED BY SONY.
ATTENTION AU COMPOSANT AYANT RAPPORT
À LA SÉCURITÉ!!
LES COMPOSANTS IDENTIFIÉS PAR UNE MARQUE 0 SUR LES
DIAGRAMMES SCHÉMATIQUES ET LA LISTE DES PIÈCES
SONT CRITIQUES POUR LA SÉCURITÉ DE FONCTIONNEMENT.
NE REMPLACER CES COMPOSANTS QUE PAR DES PIÈCES
SONY DONT LES NUMÉROS SONT DONNÉS DANS CE MANUEL
OU DANS LES SUPPLÉMENTS PUBLIÉS PAR SONY.
SECTION 1
GENERAL
This section is extracted from
CDX-C5000X/C5005’s instruction manual.
3
4
5
6
7
8
9
SECTION 2
DISASSEMBLY
Note : Follow the disassembly procedure in the numerical order given.
2-1. SUB PANEL (CD) ASSY
4 two claws
6 sub panel (CD) assy
2 PTT 2.6x6
3 claw
5 CNP800
1 PTT 2.6x6
2-2. CD MECHANISM BLOCK
7 bracket (CD)
6 PTT 2.6x6
5 CD mechanism block
2 PTT 2.6x6
3
1 PTT 2.6x6
4 CN301
10
2-3. MAIN BOARD
6 MAIN board
4 PTT 2.6x6
5 PTT 2.6x6
3 PTT 2.6x8
2 PTT 2.6x8
1 PTT 2.6x8
2-4. HEAT SINK
7 heat sink
6 PTT 2.6x8
5 PTT 2.6x8
4 PTT 2.6x8
3 PTT 2.6x12
2 PTT 2.6x8
1 PTT 2.6x8
11
2-5. CHASSIS (T) SUB ASSY
2 P 2x3
3 P 2x3
1 Unsolder the
lead wires.
4 chassis (T) sub assy
black
red
white
2-6. LEVER SECTION
5 guide (disc)
6 lever (R)
3 tension spring (LR)
7 lever (L)
1 PS 2x3
2 DISC IN SW board
4 claws
12
2-7. SERVO BOARD
7 PS 2x4
6 PS 2x4
2 CN2
3 Removal the solders.
1 CN3
4 P 2x3
8 SERVO board
5 loading motor assy
2-8. SHAFT ROLLER ASSY
• When installing, take note of the positions
arm (roller) and washers. (Fig. 1)
3 retaing ring (RA)
4 shaft retainer
shaft retainer
retaing ring (RA) arm washer
arm
washer
shaft retainer
Fig. 1
5 shaft roller assy
2 arm (roller)
1 tension spring (RA)
13
2-9. FLOATING BLOCK ASSY
6 floating block assy
7 compression spring (FL)
1 tension spring (KF1)
8 compression spring (FL)
4 Fit lever (D) in the
direction of the arrow.
5 Turn loading ring in the
direction of the arrow.
2 damper (T)
3 damper (T)
2-10. OPTICAL PICK-UP BLOCK
1 P 2x3
2 sled motor assy
3 optical pick-up block
14
SECTION 3
DIAGRAMS
3-1. IC PIN DESCRIPTIONS
• IC501 CXD2598Q (DIGITAL SERVO, DIGITAL SIGNAL PROCESSOR) (SERVO BOARD)
Pin No.
Pin Name
I/O
Pin Description
1
DVDD
—
Digital power supply pin
2
3
DVSS
SOUT
—
O
Digital ground
Servo brock serial data output (Not used.)
4
5
SOCK
XOLT
O
O
Servo brock serial data read clock output (Not used.)
Servo brock serial data latch output (Not used.)
6
7
SQSO
SQCK
O
I
Sub Q 80 bit, PCM peak and level data output. CD TEXT data output
Clock input from SQSO read output.
8
9
SCSY
SBSO
I
O
Fixed at “L”.
Serial output of sub-P to W. (Not used.)
10
11
EXCK
XRST
I
I
Clock input from SBSO read output. (Fixed at “L”)
System reset (“L”: Reset)
12
13
STSM
DATA
I
I
System mute input (Fixed at “L”)
Serial data input from CPU.
14
15
XLAT
CLOK
I
I
Latch input from CPU. Latch serial data at the falling edge.
Serial data transfer clock input from CPU.
16
17
SENS
SCLK
O
I
SENS output for CPU.
Clock input from SENS serial data read.
18
19
ATSK
WFCK
I/O
O
20
21
XUGF
XPCK
O
O
XUGF output (Not used.)
XPCK output (Not used.)
22
23
24
GFS
C2PO
SCOR
O
O
O
GFS output
C2PO output (Not used.)
“H” output at either detection, sub code sync S0 or S1.
25
26
C4M
WDCK
O
O
4.2336 MHz output (Not used.)
Word clock input f=2Fs (Not used.)
27
28
COUT
MIRR
I/O
I/O
Track number count signal input/output (Not used.)
Mirror signal input/output (Not used.)
29
30
DVSS
DVDD
—
—
Digital ground
Digital power supply pin
31
32
DFCT
FOK
I/O
I/O
Diffect signal input/output (Not used.)
Focus OK signal output
33
34
PWM1
LOCK
I
I/O
External control input of spindle motor.
Lock signal input/output
35
36
MDP
SSTP
O
I
37
38
FSTIO
SFDR
I/O
O
39
40
SRDR
TFDR
O
O
Sled drive output
Tracking drive output
41
42
TRDR
FFDR
O
O
Tracking drive output
Focus drive output
43
44
FRDR
DVDD
O
—
Focus drive output
Digital power supply pin
45
46
DVSS
TEST
—
I
Digital ground
Test pin (Fixed at “L”.)
47
48
TES1
XTSL
I
I
Test pin (Fixed at “L”.)
X’tal select input (“L”: 16.9344 MHz, “H”: 33.8688 MHz)
49
50
VC
FE
I
I
Center voltage input
Focus error signal input
51
SE
I
Sled error signal input
Input/output for anti-shock.
WFCK (Write Flame Clock) output (Not used.)
Servo control output of spindle motor.
Disc most inner track detection signal input
2/3 frequency division output of pins ih and ij. (Not used.)
Sled drive output
15
Pin No.
Pin Name
I/O
52
53
TE
CE
I
I
Tracking error signal input
Center servo analog input
54
55
RFDC
ADIO
I
O
RF signal input
Test pin (Not used.)
56
57
AVSSO
IGEN
—
I
Analog ground
Constant current input from OP amplifier.
58
59
AVDDO
ASYO
—
O
Analog ground
EFM full-swing output (“L”: VSS, “H”: VDD)
60
61
ASYI
RFAC
I
I
62
63
AVSS3
CLTV
—
I
Analog ground
VCO control voltage input from master.
64
65
FILO
FILI
O
I
Filter output for master PLL (slave=digital PLL)
Filter input from master PLL.
66
67
PCO
AVDD3
O
—
Charge pump output for master PLL.
Analog power supply pin
68
69
BIAS
VCTL
I
I
Asymmetry circuit constant current input
VCO2 control input from wideband EFM PLL. (Not used.)
70
71
V16M
VPCO
O
O
VCO2 oscillator output for wideband EFM PLL. (Not used.)
Charge pump output for wideband EFM PLL. (Not used.)
72
73
DVSS
MD2
—
I
Digital ground
Digital out ON/OFF control input (“L”: OFF, “H”: ON)
74
75
DOUT
ASYE
O
I
Digital out output
Asymmetry circuit ON/OFF input (“L”: OFF, “H”: ON)
76
77
DVDD
LRCK
—
O
Digital power supply pin
D/A interface LR clock output (f=Fs)
78
79
LRCKI
PCMD
I
O
D/A interface LR clock input
D/A interface serial data output (2’s COMP, MSB fast)
80
81
PCMD
BCK
I
O
D/A interface serial data input (2’s COMP, MSB fast)
D/A interface bit clock output
82
83
BCKI
EMPH
I
O
D/A interface bit clock input
Emphasis ON/OFF signal output
84
85
EMPHI
XVDD
I
—
Emphasis ON/OFF signal input (“H”: ON, “L”: OFF)
Power supply for master clock.
86
87
XTAI
XTAO
I
O
X’tal oscillator input from master clock (16.9344 MHz).
X’tal oscillator output for master clock (16.9344 MHz).
88
89
XVSS
AVDD1
—
—
Ground pin for master clock.
Analog power supply pin
90
91
AOUT1
AIN1
O
I
Lch analog output
Lch OPAMP input
92
93
LOUT1
AVSS1
O
—
Lch LINE output
Analog ground
94
95
AVSS2
LOUT2
—
O
Analog ground
Rch LINE output
96
97
AIN2
AOUT2
I
O
Rch OPAMP input
Rch analog output
98
99
AVDD2
RMUT
—
O
Analog power supply pin
Rch “0” detect Flug (Not used.)
100
LMUT
O
Lch “0” detect Flug (Not used.)
16
Pin Description
Asymmetry comparate voltage input
EFM signal input
• IC5 CXP84640-072Q (CD SYSTEM CONTROL) (SERVO BOARD)
Pin No.
Pin Name
I/O
1
ITRPT
—
Not used in this set.
Pin Description
2, 3
4, 5
—
NCO
—
—
Not used in this set.
Not used in this set.
6
7
OPEN
CLOSE
I
O
Front panel open detection input
Front panel close control output
8
9
LINKOFF
NCO
I
—
Bus interface link input
Not used in this set.
10
11
D SW
SSTP
I
I
12, 13
14, 15
NCO
—
—
—
Not used in this set.
Not used in this set.
16
17
EMPH O
CDMON
O
O
De-emphasis ON/OFF control output
CD mechanism deck power control output
18
19
CD ON
A MUT
O
O
CD power control output
System attenuate control output
20
21
LD ON
CD RST
O
O
Laser power ON/OFF control output
CD system reset output
22
23
HOLD
AGC CONT
O
O
Hold switch output
AGC control output
24
25
—
PH3
—
I
Not used in this set.
Not used in this set.
26
27
TSTIN0
TSTIN1
I
I
Not used in this set.
Not used in this set.
28
29
30
TST.CLV
NCO
RESET
I
—
I
Not used in this set.
Not used in this set.
System reset input (“L”=Reset)
31
32
X IN
X OUT
I
O
X’tal oscillator input from system clock. (10 MHz)
X’tal oscillator output for system clock. (10 MHz)
33
34
GND
XT OUT
—
O
Analog ground
Not used in this set.
35
36
XT IN
AVSS
I
—
Not used in this set.
A/D converter ground
37
38
AVREF
TEP L
I
I
A/D converter reference voltage input
Not used in this set.
39
40
TEP H
SLED–
I
I
Not used in this set.
Sled drive input
41
42
PH2
SEK/SMET
I
I
Not used in this set.
Fixed at “H” in this set.
43
44
GFS/MNT2 SEL
SC-JIG ON/OFF
I
I
Fixed at “H” in this set.
Fixed at “H” in this set.
45
46
SCLK
LOCK
O
I/O
CD-TEXT data read clock output
Lock signal input/output
47
48
—
SCK2
—
O
Not used in this set.
Sub Q read clock output
49
50
SI2
—
I
—
Sub Q 80 bit, PCM peak and level data 16 bit input.
Not used in this set.
51
52
BUS CLK
BUS SI
I/O
I
Bus system serial clock input/output
Bus system serial interface input
53
54
BUS SO
F OK
O
I
Bus system serial interface output
Focus OK signal input
55
56
GFS
TEST MODE
I
I
GFS signal detection input
Fixed at “H” in this set.
Down switch input (SW4)
Limit switch input (SW3)
17
Pin No.
57
Pin Name
SENS
I/O
I
SENS signal input
58
59
—
—
—
—
Not used in this set.
Not used in this set.
60
61
BU.IN
BUSON
I
I
Back-up power detection input
Bus on control input
62
63
IN SW
SELF SW
I
I
Disc in switch input (SW1)
Self switch input (SW2)
64
65
SCOR
CD-CKO
O
O
Sub-code sync output
CD signal process serial clock input
66
67
LM LOD
CD DATA
O
O
Loading motor control output
CD signal process serial data output
68
69
CD-XLAT
LM-EJ
O
O
CD signal process serial data latch output
Loading motor control output
70
71
DRV-OE
MD2
O
O
Focus/tracking coil/sled motor control output
Digital out ON/OFF control output (“L”: OFF, “H”: ON)
72
73
VDD
NIH
—
I
Power supply pin
Fixed at “H” in this set.
74
75
V/Z
PH1
I
I
Fixed at “H” in this set.
Not used in this set.
76
77
—
DOUT-SEL
—
I
Not used in this set.
Fixed at “H” in this set.
78 – 80
—
—
Not used in this set.
18
Pin Description
• IC801 MN101C49KTB (SYSTEM CONTROL) (MAIN BOARD)
Pin No.
Pin Name
I/O
Pin Description
1
VREF–
—
Ground for A/D converter power supply
2
3
S METER
FM AGC
I
I
S meter voltage detect signal input
FM auto gain control signal input
4
5
KEY IN1
KEY IN0
I
I
KEY signal input
KEY signal input
6
7
DSTSEL
RC IN0
I
I
C5000X/C5005: Not used.
C6800X: Frequency select signal input
Rotary commander signal input
8
9
FUNC SEL
NIL
I
—
Model function selection pin
Ground
10
11
VREF+
VDD
—
—
A/D converter power supply
Power supply (+5 V) input pin
12
13
OSC OUT
OSC IN
O
I
High speed clock signal output (18.432 MHz)
High speed clock signal input (18.432 MHz)
14
15
VSS
XI
—
I
Ground for power supply
Low speed clock signal input (32 kHz)
16
17
XO
MMOD
O
—
Low speed clock signal output (32 kHz)
Not used. (Fixed at “L”.)
Memory mode select signal input
18
19
RC IN1
SYSRST
I
O
Rotary commander shift key signal input
System reset signal output
20
21
BUS ON
LCD DATA
O
O
Bus on control signal output
LCD serial data signal output
22
23
LCD CE
LCD CLK
O
O
LCD chip enable signal output
LCD serial clock signal output
24
25
26
ILL ON
DOOR IND
KEY ACK
O
O
I
Illumination power supply control signal output
Control signal output for power on sub panel when open to front panel
Key active interrupt detect signal input
27
28
NOSE
BU IN
I
I
Front panel attachment detection input
Back up power supply setect signal input
29
30, 31
SIRCS
NC
I
—
Remote control signal input
Not used. (Fixed at “L”.)
32
33
RAM
RESET
—
I
Not used.
Reset signal input
34
35
NC
BEEP
—
O
Not used.
Beep signal input
36
37
NC (FUNC SEL)
NC (FUNC SEL)
I
I
38 – 40
41
NC
UNI CLI
—
I
Not used.
Bus system serial clock signal input
42
43
UNI SO
UNI SI
O
I
Bus system serial interface signal output
Bus system serial interface signal input
44
45
UNI CLO
SDA
O
I/O
Bus system serial clock signal output
I2C bus serial data signal input/output
46
47
NC
SCL
—
O
Not used.
I2C bus serial clock signal output
48, 49
50
NC
LOCK
—
I
Not used.
Check when remove to lock of MDNO CLV SERVO
51 – 63
64
NC
ACC IN
—
I
Not used.
Accessory power supply voltage detection input
65
66
TEL MUT
TEST IN
I
I
Telephone attenuate detect signal input
Test mode setting detect first stage signal input
67
68
ANT CUT
NC
—
—
Model function selection pin
Model function selection pin
Not used.
Not used.
19
Pin No.
69
Pin Name
AMP ON
I/O
O
70
71
MUT
AMP MUT
O
O
System attenuate control signal output
Power amp attenuate control signal output
72
73
VOL MUT
TU ON
O
O
Mute control signal output for electrical volume
Tuner attenuate signal output
74
75
EEP SDA
EEP SCL
I/O
O
Tuner EEPROM serial data signal input/output
Runer EEPROM serial clock signal output
76
77
IF BW
NC
I
—
Not used.
Not used.
78
79
NC
REIN1
—
I
Not used.
Rotary encoder signal input
80
81
REIN0
AD ON
I
O
Rotary encoder signal input
Power control output for A/D conversion
82 – 92
93
NC
OPEN
—
I
Not used.
Front panel open/close condition signal input
94 – 98
99
NC
PW ON
—
O
Not used.
System power supply control signal output
100
NC
—
Not used.
20
Pin Description
Power supply on/off control signal output
Tuner switch VCO level shift signal input
CDX-C5000X/C5005/C6800X
3-2. BLOCK DIAGRAM — CD SECTION —
RF AMP, LD APC,
ERROR AMP
IC1
OPTICAL PICKUP
KSS-720A
DIGITAL SERVO,
DIGITAL SIGNAL PROCESSOR
IC501
A
A
5
C
B
C
7
B
6
RF
EQ
RFO
16
61
RFAC
EFM
DEM
D/A
I/F
D/A
CONV.
LOUT1
LOUT2
CD L
92
95
I-V
CONV.
8
DIGITAL
CLV
FE
E
11
F
10
E
F
PD
4
TRACKING
ERROR
TE
LD
3
50
13
52
51
PD
LOCK
TE
SUB
CODE
PROCESS
SE
SQSO
SQCK
SCOR
MD2
XRST
DATA
XLAT
SCLK
CLOK
SENS
GFS
FOK
TRACKING/FOCUS COIL DRIVE
SLED/SPINDLE/LOADING MOTOR DRIVE
IC7
FOCUS
COIL
DRIVE
22
42
21
43
25
40
9
TRACKING
COIL
DRIVE
24
41
6
7
SLED
MOTOR
DRIVE
31
32
38
39
FOCUS
COIL
10
TRACKING
COIL
8
11
FFDR
6
7
24
49 SI2
48 SCK2
64 SCOR
73
11
13
14
17
15
16
22
32
71
21
67
68
45
65
57
55
54
XTALI 86
M901
SPINDLE
MOTOR
12
13
SPINDLE
MOTOR
DRIVE
18
M903
LOADING
MOTOR
5
4
LOADING
MOTOR
DRIVE
1
2
35
MD2
CD RST
CD DATA
CD XLAT
SCLK
CD CKO
SENS
GFS
FOK
70 MUT
93 OPEN
A MUT 19
OPEN 6
41
44
43
42
20
19
28
BUS CLK 51
BUS SI 52
BUS ON 61
RESET 30
BU IN 60
UNI CLI
UNI CLO
UNI SI
UNI SO
BUS ON
SYS RST
BU IN
33 RESET
IC902
X IN 31
X2
16MHz
FRDR
XTALO 87
M902
SLED
MOTOR
SYSTEM CONTROL
IC801 (1/3)
(DISPLAY BOARD)
22
HOLD SW 21
AGC CONT 20
LD
46 LOCK
34
FE
LD ON
LD
AMP
LD
DRIVE
Q101
14
B
(Page 22)
TUNER
SECTION
CD SYSTEM CONTROL
IC5
D
FOCUS
ERROR
ATT
R-CH
54 RFDC
D
A
(Page 22)
TUNER
SECTION
X OUT 32
S900
(RESET)
X1
10MHz
BU 5V
3 RESET 1
TFDR
SERVO
TRDR CTL
SFDR
SRDR
MDP
SW4
(LIMIT)
11 SSTP
SW1
(DISC IN)
10 D SW
SW3
(LOAD IN)
64 IN SW
SW2
(SELF)
MUTE 1 34
MUTE 2 35
CD +5V
REG
Q703
CD +6V
REG
Q922
LM EJ
LM LOD
SLED –
DRIVE ON
LD ON
HOLD
AGC CONT
10
BATT (L)
CHECK
3
13
RESET
2
12
BUS ON
1
+11V REG
Q920
BATT
8
9
18 CD ON
CD MECHA ON
SWITCH
Q903, 913
SIRCS
Q801
DATA
6
8
CD ON
SWITCH
Q701, 702
C
BUS INTERFACE
IC802
63 SELF SW
69
66
40
70
20
22
23
CD +5V
DISPLAY
SECTION
(Page 23)
11
17 CDM ON
Q803
BUS SO 53
CLK
6
5
4
3
2
1
7
4
BATT
CNP801
BUS
CONTROL IN
BATT
LNK OFF 8
• Signal path
CD +6V
04
: CD
21
21
CDX-C5000X/C5005/C6800X
3-3. BLOCK DIAGRAM — TUNER SECTION —
PJ400
BUS AUDIO IN
TUNER UNIT
TU601
CNJ600
(ANTENNA)
2 ANTFM
MPX 10
1 ANTAM
AM DET 8
R
L
R
–4
–1
–2
R-CH
POWER AMP
IC101
ELECTRONIC VOLUME
IC701
3 AUX L
CDL
L
–3
R-CH
A
CD
(Page 21) SECTION
R
–6
R-CH
L
–5
PJ400
AUDIO OUT REAR
AUDIO OUT FRONT
CNP501
OUT LF 30
12
5
3
OUT LR 29
11
9
8
13 MPX
Q102
MUTE
11 AM
12
14
15
20
21
18
Q101
MUTE
72 VOL MUT
2 S-MRTER
45 SDA
47 SCL
R-CH
3 RR+
11 RR–
MUTE
SWITCH
Q401, 402
BEEP
AMP ON
AMP MUTE
TEL MUT
B
ATT
16 BATT
BATT
F901
CD
SECTION
(Page 21)
35
69
71
65
TEL
MUTE
Q916
ACC
CHECK
Q905
ACC IN 64
S-METER 14
SDA 12
SCL 13
4 FR+
12 FR–
16 AUX IN
4 STAND BY
22 MUTE
AM IF
LEVEL
MPIN
SDA
SCL
MUTE
SYSTEM CONTROL
IC801 (2/3)
13 ATT
7 ACC
BATT
CHECK
Q906
BATT
15 TEST
TEST IN 66
C6800X
FM 50k
AM 9k
DSTSEL 6
POWER SUPPLY
IC901
FM 200k
AM 10k
BATT
4 VCC
5 AMP REM
AMP +B 2
SW802(FREQUENCY SELECT)
BU +B 5
PW ON 99
1 AMP ON
PULL UP +5V
BACKUP +5V
AMP +B
SWITCH
Q921
GND 3
TU ON
SWITCH
Q902
TU ON 73
COM +8V
COM +8V
REG
Q904
BATT
TU +8V
TU +8V
REG
Q602
TU +5V
REG
Q601
TU +5V
Q907
TU +8V
BACKUP +5V
TU +5V
TU ON
SWITCH
Q603
PW ON
SWITCH
Q919
FM AGC 4
SDA (EEP) 17
SCL (EEP) 18
3 FM AGC
74 EEP SDA
75 EEP SCL
DOOR IND 25
04
22
2 RL+
10 RL–
1 CD L
AM IF 19
VDD (8V) 5
IF BW 11
VDD (5V) 16
1 FL+
9 FL–
22
• Signal path
: FM
: AM
: CD
DOOR IND
SWITCH
Q908
6 ANT REM
CDX-C5000X/C5005/C6800X
3-4. BLOCK DIAGRAM — DISPLAY SECTION —
3-5. CIRCUIT BOARDS LOCATION
SYSTEM CONTROL
IC801 (3/3)
KEY MATRIX
LSW901-908
LSW910-915
S901-904
5 KEY IN0
47 KEY IN1
KEY
ACTIVE
Q914
LCD DRIVE
IC901
LCD DATA 21
LCD CE 22
LCD CLK 23
64 DATA
62 CE
63 CL
S04 4
I
I
S51 51
•
COM1 52
I
I
COM4 55
LIQUID CRYSTAL
DISPLAY PANEL
LCD901
RELAY board
C5005
81 AD ON
AMBER
DRIVE
Q901
KEY ACT
GREEN
DRIVE
Q902
F/P +10V
18 RC IN1
7 RC IN0
CNP802
(REMOTE IN)
LIMIT SW board
GREEN 2
AMBER 1
26 KEY ACK
KEY
ACTIVE
Q915
DISC IN SW board
tuner unit
(TU601)
IC951
Q802
CD
SECTION
(Page 21)
C
IR
RECEIVE
29
SIRCS
LED910-915
SIRCS
ROTARY
ENCODER
RE901
ILL ON 24
80 RE IN0
79 RE IN1
POWER
CONT
Q911
BATT
S901
(NOSE DET)
27 NOSE
X801
32.768kHz
16 XO
15 XI
OSC OUT 12
OSC IN 13
+10V REG
Q912
LSW901-908
LSW910-915
LED921-924
LED901-904 (C5005)
MAIN board
DISPLAY board
SERVO board
ILL +B
X800
14.432MHz
04
23
23
CDX-C5000X/C5005/C6800X
3-6. PRINTED WIRING BOARDS — CD MECHANISM SECTION —
THIS NOTE IS COMMON FOR PRINTED WIRING
BOARDS AND SCHEMATIC DIAGRAMS.
(In addition to this, the necessary note is
printed in each block.)
for schematic diagram:
• All capacitors are in µF unless otherwise noted. pF: µµF
50 WV or less are not indicated except for electrolytics
and tantalums.
• All resistors are in Ω and 1/4 W or less unless otherwise
specified.
•
%
: indicates tolerance.
f
•
: internal component.
• C : panel designation.
Note:
Note:
The components identi- Les composants identifiés par
fied by mark 0 or dotted une marque 0 sont critiques
line with mark 0 are criti- pour la sécurité.
Ne les remplacer que par une
cal for safety.
Replace only with part piéce portant le numéro
spécifié.
number specified.
• U : B+ Line.
• Power voltage is dc 14.4V and fed with regulated dc power
supply from ACC and BATT cords.
• Voltages are taken with a VOM (Input impedance 10 MΩ).
Voltage variations may be noted due to normal production tolerances.
• Waveforms are taken with a oscilloscope.
Voltage variations may be noted due to normal production tolerances.
• Circled numbers refer to waveforms.
• Signal path.
F : FM
f : AM
J : CD
for printed wiring boards:
• X : parts extracted from the component side.
• Y : parts extracted from the conductor side.
a
•
: Through hole.
• b : Pattern from the side which enables seeing.
(The other layer’s patterns are not indicated.)
Caution:
Pattern face side:
(Side B)
Parts face side:
(Side A)
Parts on the pattern face side seen from the
pattern face are indicated.
Parts on the parts face side seen from the
parts face are indicated.
24
24
CDX-C5000X/C5005/C6800X
• Semiconductor
Location
Ref. No. Location
IC1
C-1
IC5
C-6
IC7
F-2
IC501
F-5
Q101
(Page 30)
25
25
B-2
CDX-C5000X/C5005/C6800X
3-7. SCHEMATIC DIAGRAM — CD MECHANISM SECTION (1/2) — • Refer to page 35 for IC Block Diagrams.
(Page 27)
KSS-720A
• Waveforms (MODE:PLAY)
1
0V
Approx. 200mVp-p
IC1
qd
(TE)
2
0V
Approx. 620mVp-p
IC1
qf
(FE)
3
IC1
qh
(Page 28)
1.2Vp-p
(RFO)
Note:
• Voltage and waveforms are dc
with respect to ground
under no-signal conditions.
no mark : CD PLAY
: Impossible to measure
∗
(Page 27)
26
26
CDX-C5000X/C5005/C6800X
3-8. SCHEMATIC DIAGRAM — CD MECHANISM SECTION (2/2) — • Refer to page 36 for IC Block Diagrams.
(Page 26)
(Page 26)
Note:
• Voltage and waveforms are dc with respect to ground
under no-signal conditions.
no mark : CD PLAY
: Impossible to measure
∗
27
27
CDX-C5000X/C5005/C6800X
3-9. SCHEMATIC DIAGRAM — MAIN SECTION (1/2) — • Refer to page 36 for IC Block Diagrams.
(Page 29)
(Page
26)
(Page 32)
Note:
• Voltage is dc with respect to ground under no-signal
(detuned) condition.
no mark : FM
(
) : AM
<
> : CD PLAY
28
28
CDX-C5000X/C5005/C6800X
(Page 28)
3-10. SCHEMATIC DIAGRAM — MAIN SECTION (2/2) — • Refer to page 35 for IC Block Diagrams.
Note:
• Voltage is dc with respect to ground
under no-signal (detuned) condition.
no mark : FM
(
) : AM
<
> : CD PLAY
29
29
CDX-C5000X/C5005/C6800X
3-11. PRINTED WIRING BOARD — MAIN SECTION —
(Page 25)
• Semiconductor Location
Ref. No. Location
Ref. No.
D924
D401
G-8
D925
D402
H-7
D926
D404
C-5
D927
D405
F-7
D928
D601
I-1
D930
D603
I-2
D701
E-14
IC101
D702
I-5
IC701
D801
H-9
IC801
D802
H-10
IC802
D803
D-12
IC901
D806
D-12
IC902
D807
F-12
D808
E-11
Q101
D809
D-12
D810
J-3
Q102
D811
J-3
Q201
D812
J-3
Q202
D813
J-3
Q401
D814
J-3
Q402
D815
J-3
Q601
D816
J-4
Q602
D817
J-4
Q603
D818
J-4
Q701
D820
G-10
Q702
D821
F-11
Q703
D822
B-14
Q801
D823
B-13
Q802
D901
B-11
Q803
D902
D-11
Q902
D903
C-11
Q903
D904
G-12
Q904
D905
H-14
Q905
D906
I-14
Q906
D907
E-12
Q907
D909
F-12
Q908
D910
F-8
Q911
D911
D-7
Q912
D913
K-8
Q913
D914
D-8
Q914
D915
J-5
Q915
D917
D-7
Q916
D918
B-14
Q919
D921
C-8
Q920
D922
C-8
Q921
D923
C-8
Q922
(Page 31)
30
30
Location
C-8
C-7
C-7
C-7
C-7
D-10
B-8
H-4
I-8
F-11
F-13
J-12
C-5
C-3
C-5
C-4
G-6
G-7
I-1
J-2
J-1
E-13
F-13
D-13
E-11
E-10
F-11
D-7
C-14
H-14
E-7
F-8
I-13
H-12
K-13
I-12
C-14
K-7
J-5
E-7
I-12
B-13
C-10
G-14
CDX-C5000X/C5005/C6800X
3-12. PRINTED WIRING BOARD — RELAY SECTION —
(Page 30)
(Page 34)
31
31
CDX-C5000X/C5005/C6800X
3-13. SCHEMATIC DIAGRAM — RELAY SECTION —
(Page 28)
(Page 33)
32
32
CDX-C5000X/C5005/C6800X
3-14. SCHEMATIC DIAGRAM — DISPLAY SECTION —
(Page 32)
Note:
• Voltage is dc with respect to ground under no-signal
(detuned) condition.
no mark : FM
33
33
CDX-C5000X/C5005/C6800X
3-15. PRINTED WIRING BOARD — DISPLAY SECTION —
(Page 31)
• Semiconductor Location
Ref. No. Location
Ref. No.
(D902)
B-10
LED911
(D903)
B-10
LED912
(D905)
A-6
LED913
(D951)
C-5
LED914
LED915
(IC901)
B-8
LED921
IC951
C-6
LED922
LED923
<LED901> A-2
LED924
<LED902> C-2
<LED903> C-3
[Q901]
<LED904> A-3
[Q902]
LED910
B-13
(
<
[
34
34
) : SIDE B
> : CDX-C5005 only
] : SIDE B, CDX-C5005 only
Location
A-13
A-5
B-5
B-13
B-5
A-2
C-2
C-4
A-4
A-3
A-3
3-16. IC BLOCK DIAGRAMS
IC1 CXA2596M-T6
APC PD AMP
HOLD
+
–
1
VCC
VCC
VEE
AGCVTH
+
–
23 LC/PD
2
VEE
+
–
VREF
1.25V
LD
3
PD
4
A
5
+
–
APC LD AMP
22 LD ON
VCC
VC
21 HOLD SW
+
–
B
24 VCC
+
–
20 AGCCONT
+
–
+
–
6
19 RF BOT
VC
+
–
VEE
C
+
–
VC
D
18 RFTC
7
+
–
VC
17 RF I
8
RF SUMMING AMP
RF EQ AMP
VC
VEE
VEE
9
F 10
15 RFE
–
+
E 11
VC
VC BUFFER
BUS ON
OUT 1
BUS ON
SWITCH
RST 2
OUT
RESET
SWITCH
BATT 3
BATTERY
SWITCH
14 VCC
14 FE
VC
VC 12
IC802 BA8270F-E2
+
–
+
–
VC
16 RFO
ERROR AMP
FOCUS
VC
–
+
13 TE
VCC
VEE
+
–
TRACKING
ERROR AMP
13
12
11
10
RST
BUS ON IN
CLK IN
BATT
CHECK
VC
CLK OUT 4
VREF 5
DATA 6
IN/OUT
VC
GND 7
9 DATA IN
8 DATA OUT
IC901 BA4903ST-V5
5.7V
ON
ON
–
+
+
THERMAL
SHUT
DOWN
CIRCUIT ON
1
AMP
ON
2
AMP
B+
3
GND
–
REGULATOR
VREF
OVER
VOLTAGE
PROTECT
4
VCC
5
BU+B
35
IC7 LA6556
FWD
GND
1
36 S-GND
INPUT
REV
2
CH2-CH4 OUTPUT
ON/OFF
MUTE2
35 MUTE2
VCC2
3
CH1 OUTPUT
ON/OFF
MUTE1
34 MUTE1
VL0–
4
33 VIN4
OUTPUT
CONTROL
VO4+
32 VIN4–
5
+
–
+
–
VL0+
6
31 VIN4+
LEVEL
SHIFT
7
VO3+
8
+
–
VO4–
30 VREF-IN
VIN1/VREF SW
29 VIN1 (VREF)-SW
LEVEL
SHIFT
VO3–
28 VREF-OUT (CH1)
9
–
+
5V REG
+
–
VO2+ 10
27 REG-OUT
LEVEL
SHIFT
26 REG-IN
VO2– 11
VO1+ 12
25 VIN3+
VO1– 13
+
–
LEVEL
SHIFT
+
–
24 VIN3–
23 VIN3
VCC1 14
–
+
VIN1 15
+
–
VIN1–A 16
VIN1+A 17
VIN1–B 18
AMP-A
–
+
–
+
21 VIN2–
20 VIN2
19 VIN1 +B
AMP-B
36
22 VIN2+
+
–
ACINLR
ACINLR
ACINRR
OUTLF
OUTLR
OUTRF
OUTRR
OUTSWL
OUTSWR
OUTSSL
OUTSSR
IC701 TDA7402TR
33
32 31
30 29
28 27
26 25
24 23
MONO
FADER
SUPPLY
22 VDD
MIXER
MONO
FADER
MONO
FADER
21 SCL
20 SDA
SUBWOOFER
+PHASE
CONTROL
19 GND
ACINLF 34
SWINR 35
SWINL 36
OUTPUT CONTROL
18 MUTE
AC OUTR 37
AC OUTL 38
VOICE
BANDPASS
IIC-BUS
LP
17 QUAL
QUAL.
HP
D/A
BASS
HIGH OUT
DIGITAL
CONTROL
TRABLE
VREF 39
PULSE
FORMER
S&H
VOLUME
SOFT MUTE
LOUDNESS
AM/FM
NOISE
BLANKER
COMPANDER
LP
MALTI
PATH
DETECTOR
DEMODULATOR
+STEREO ADJUST
+STEREO BLAND
LOUDNESS
MUX 40
16 MP OUT
15 MP IN
IN GAIN
IN GAIN
+ AUTO
ZERO
MUTE
BEEP
PILOT
CANCELLATION
PIL, DET
MAIN SOURCE
SELECTOR
41
42
43
44
SECOND SOURCE
SELECTOR
PLL
14 LEVEL
INPUT MULTIPLEXER
LP
13 MPX
12 AMIF
1 2 3 4 5 6 7 8 9 10 11
CD L
CD R
AUX L
SE2L
AUX R
SE2R
FD2L+
FD2L–
FD2R+
FD2R–
AM
MD1 (SE4L)
MD1G (SE4R)
MD2
MD2G
MIXING
SELECTOR
37
SECTION 4
EXPLODED VIEWS
NOTE:
• The mechanical parts with no reference
number in the exploded views are not supplied.
• Items marked “*” are not stocked since
they are seldom required for routine service.
Some delay should be anticipated
when ordering these items.
• -XX and -X mean standardized parts, so
they may have some difference from the
original one.
• Color Indication of Appearance Parts
Example :
KNOB, BALANCE (WHITE) ... (RED)
R
R
Parts Color Cabinet’s Color
• Accessories and packing materials and
hardware (# mark) list are given in
the last of this parts list.
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
Les composants identifiés par une
marque 0 sont critiques pour
la sécurité.
Ne les remplacer que par une piéce
portant le numéro spécifié.
4-1. CHASSIS SECTION
9
11
MG-383Z-121//K
#2
#2
#1
#1
#1
#1 #3
12
8
16
15
14
#1
#1
13
#1
#1
10
TU601
4
#1
3
1
F901
12
19
2
#2
5
7
#2
6
#5
#2
#5
#5
18
#2
#2
17
Ref. No.
Part No.
Description
Ref. No.
Part No.
Description
1
2
* 3
4
5
X-3378-387-1
3-041-039-01
1-676-690-11
X-3376-686-2
3-030-909-02
PANEL ASSY (CD), SUB
BUTTON (EJECT)
RELAY BOARD
GEAR ASSY
DAMPER, OIL
* 11
12
* 13
* 14
* 15
3-041-173-01
3-376-464-11
3-019-565-01
3-041-157-01
3-041-174-01
BRACKET (CD)
SCREW (+PTT 2.6X6), GROUND POINT
BRACKET (IC)
HEAT SINK (6P)
HEAT SINK (REG)
6
7
* 8
9
* 10
X-3376-687-1
3-713-786-51
3-041-156-01
1-792-194-21
A-3294-805-A
LOCK ASSY
SCREW +P 2X3
COVER
CORD (WITH CONNECTOR) (POWER)
MAIN BOARD, COMPLETE (C5005)
* 16
* 17
18
* 19
F901
3-041-261-01
3-041-155-01
3-035-250-02
X-3376-689-1
1-532-877-11
BRACKET (TR)
CHASSIS
SCREW (LOCK)
BRACKET (GEAR) ASSY
FUSE (BLADE TYPE) (AUTO FUSE) 10A
* 10
* 10
A-3294-874-A MAIN BOARD, COMPLETE (C6800X)
A-3294-877-A MAIN BOARD, COMPLETE (C5000X)
38
Remark
TU601
A-3220-738-A TUNER UNIT (TUX-020)
Remark
4-2. FRONT PANEL SECTION
#4
#4
57
#4
not supplied
(DISPLAY board)
55
66
65
LCD901
64
63
62
60
54
61
53
59
58
52
67
51
56
Ref. No.
Part No.
Description
Ref. No.
Part No.
Description
51
52
52
53
54
3-041-028-01
3-041-029-01
3-041-029-11
3-041-030-01
3-042-967-01
BUTTON (SOURCE)
KNOB (VOL) (C5000X/C5005)
KNOB (VOL) (C6800X)
BUTTON (CROSS)
CUSHION (CROSS)
60
61
62
63
* 64
3-041-036-01
3-041-033-01
3-041-035-01
3-041-034-01
3-041-175-01
BUTTON (1-6/M)
BUTTON (LIST/ENTER)
BUTTON (OFF)
BUTTON (MENU/SOUND)
PLATE (LCD), GROUND
* 55
56
56
56
57
X-3378-426-1
X-3378-394-1
X-3378-605-1
X-3378-606-1
X-3378-391-1
HOLDER (LCD) ASSY
PANEL (S) ASSY, FRONT (C5005)
PANEL (S) ASSY, FRONT (C5000X)
PANEL (S) ASSY, FRONT (C6800X)
PANEL ASSY, FRONT BACK
65
* 66
67
LCD901
LCD901
1-694-660-11
3-041-372-01
3-041-038-01
1-803-907-11
1-803-907-31
CONDUCTIVE BOARD, CONNECTION
SHEET (REFLECTOR)
BUTTON (D)
DISPLAY PANEL, LIQUID CRYSTAL (C5005)
DISPLAY PANEL, LIQUID CRYSTAL
(C5000X/C6800X)
58
59
Remark
Remark
3-041-037-01 BUTTON (OPEN)
3-032-321-01 SPRING (OPEN)
39
4-3. CD MECHANISM SECTION (1)
(MG-383Z-121//K)
102
#8
#8
104
103
107
109
101
116
115
114
106
114
105
105
C
113
M903
111
C
110
#9
112
#7
#7
108
Ref. No.
Part No.
Description
* 101
102
103
104
105
1-676-709-11
3-040-039-01
3-040-038-01
3-040-050-01
3-040-022-01
DISC IN SW BOARD
CHASSIS (T)
SPRING (LR), TENSION
LEVER (L)
RETAINER (RA), SHAFT
106
107
108
109
3-040-044-01
3-040-067-01
A-3301-980-A
3-040-037-01
ROLLER (S)
LEVER (R)
SHAFT ROLLER ASSY
GUIDE (DISC)
40
Remark
#8
Ref. No.
Part No.
Description
110
* 111
* 112
113
114
3-040-040-01
A-3294-809-A
3-040-048-01
3-040-034-01
3-040-042-01
ARM (ROLLER)
SERVO BOARD, COMPLETE
BRACKET (MOTOR)
SPRING (RA), TENSION
WASHER
115
116
M903
3-043-880-01 RING (RA), RETAING
3-338-737-01 SCREW (2X3), PS
A-3301-978-A MOTOR SUB ASSY, LO (LOADING)
Remark
4-4. CD MECHANISM SECTION (2)
(MG-383Z-121//K)
154
151
156
157
157
158
D
164
160
155
162
153
165
163
161
D
159
152
152
152
Ref. No.
Part No.
Description
151
152
153
154
155
3-040-025-01
3-040-031-01
3-040-056-01
3-040-024-01
3-040-053-01
ARM, CHUCKING
DAMPER (T)
LEVER (D)
RETAINER (DISC)
RING, LOADING
156
157
158
3-040-026-01 SPRING (CH), TENSION
3-040-032-01 SPRING (FL), COMPRESSION
3-040-033-01 SPRING (KF1), TENSION
Remark
Ref. No.
Part No.
Description
159
160
161
162
163
A-3307-422-A
3-040-059-01
3-040-057-01
3-040-058-01
3-040-052-01
CHASSIS (M) COMPLETE ASSY
SPRING (TR), TENSION
LEVER (LOCK)
GEAR (MDL)
WHEEL (U), WORM
164
165
3-040-051-01 LEVER (TR)
3-040-054-01 WHEEL (LW), WORM
Remark
41
4-5. CD MECHANISM SECTION (3)
(MG-383Z-121//K)
201
M901
207
202
M902
203
208
#10
209
210
#8
204
205
206
211
#8
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
Ref. No.
Part No.
Description
* 201
202
203
204
205
X-3378-480-1
3-040-029-01
3-040-045-01
3-040-194-01
A-3301-983-A
CHASSIS (OP) ASSY (INCLUDING M901)
SPRING (SL), TORSION
BASE (DRIVING)
GEAR (SL MIDWAY)
SHAFT (FEED) ASSY
206
42
1-676-707-11 PICK-UP FLEXIBLE BOARD
Remark
Les composants identifiés par une
marque 0 sont critiques pour la
sécurité.
Ne les remplacer que par une piéce
portant le numéro spécifié.
Ref. No.
Part No.
Description
207
* 208
209
0 210
211
1-677-182-11
1-676-708-11
3-909-607-01
8-820-103-03
3-040-030-01
MOTOR FLEXIBLE BOARD
LIMIT SW BOARD
SCREW
PICK-UP, OPTICAL KSS-720A/K1RP
SPRING (FEED), PLATE
M902
A-3301-985-A MOTOR ASSY, SLED (SLED)
Remark
SECTION 5
ELECTRICAL PARTS LIST
NOTE:
• Due to standardization, replacements in
the parts list may be different from the
parts specified in the diagrams or the
components used on the set.
• -XX and -X mean standardized parts, so
they may have some difference from the
original one.
• RESISTORS
All resistors are in ohms.
METAL:Metal-film resistor.
METAL OXIDE: Metal oxide-film resistor.
F:nonflammable
• Items marked “*” are not stocked since
they are seldom required for routine service.
Some delay should be anticipated
when ordering these items.
• SEMICONDUCTORS
In each case, u : µ, for example:
uA.. : µA.. uPA.. : µPA..
uPB.. : µPB.. uPC.. : µPC.. uPD.. : µPD..
• CAPACITORS
uF : µF
• COILS
uH : µH
DISC IN SW
DISPLAY
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
Les composants identifiés par une
marque 0 sont critiques pour
la sécurité.
Ne les remplacer que par une piéce
portant le numéro spécifié.
When indicating parts by reference
number, please include the board.
Ref. No.
Part No.
Description
Remark
*
1-676-709-11 DISC IN SW BOARD
****************
< SWITCH >
SW2
1-529-566-21 SWITCH, PUSH (1 KEY) (SELF)
SW3
1-529-566-21 SWITCH, PUSH (1 KEY) (DISC IN)
*************************************************************
DISPLAY BOARD
**************
1-694-660-11 CONDUCTIVE BOARD, CONNECTION
3-041-175-01 PLATE (LCD), GROUND
3-041-372-01 SHEET (REFLECTOR)
*
*
< CAPACITOR >
C951
C952
C953
1-163-037-11 CERAMIC CHIP
1-107-823-11 CERAMIC CHIP
1-163-251-11 CERAMIC CHIP
0.022uF
0.47uF
100PF
10%
10%
5%
25V
16V
50V
< CONNECTOR >
CN901
1-794-065-11 PLUG, CONNECTOR 14P
< DIODE >
D902
D903
D905
D951
8-719-068-68
8-719-422-64
8-719-988-61
8-719-420-90
DIODE
DIODE
DIODE
DIODE
SDZ6V2WA
MA8062-M-TX
1SS355TE-17
MA8051-M-TX
< IC >
IC901
IC951
8-759-365-90 IC LC75824W
8-749-017-35 IC KSM-401N
< JUMPER RESISTOR >
JR901
1-216-295-00 SHORT
Ref. No.
Part No.
Description
LED904
LED910
LED911
LED912
LED913
8-719-078-21
8-719-078-19
8-719-078-19
8-719-078-19
8-719-078-19
LED
LED
LED
LED
LED
SML-310PT (C5005)
LWA673-R1S2
LWA673-R1S2
LWA673-R1S2
LWA673-R1S2
LED914
LED915
LED921
LED921
LED922
8-719-078-19
8-719-078-19
8-719-078-22
8-719-078-83
8-719-078-22
LED
LED
LED
LED
LED
LWA673-R1S2
LWA673-R1S2
SML-310YT (C5005)
SML-310VT (C5000X/C6800X)
SML-310YT (C5005)
LED922
LED923
LED923
LED924
LED924
8-719-078-83
8-719-078-22
8-719-078-83
8-719-078-22
8-719-078-83
LED
LED
LED
LED
LED
SML-310VT (C5000X/C6800X)
SML-310YT (C5005)
SML-310VT (C5000X/C6800X)
SML-310YT (C5005)
SML-310VT (C5000X/C6800X)
Remark
< SWITCH >
LSW901 1-771-610-11 SWITCH, TACTILE (WITH LED) (OFF) (C5005)
LSW901 1-771-883-21 SWITCH, TACTILE (WITH LED) (OFF)
(C5000X/C6800X)
LSW902 1-762-620-21 SWITCH, KEY BOARD (WITH LED) (SOURCE)
(C5005)
LSW902 1-771-476-11 SWITCH, KEY BOARD (WITH LED) (SOURCE)
(C5000X/C6800X)
LSW903 1-762-620-21 SWITCH, KEY BOARD (WITH LED) (SOUND)
(C5005)
LSW903 1-771-476-11 SWITCH, KEY BOARD (WITH LED) (SOUND)
(C5000X/C6800X)
LSW904 1-762-620-21 SWITCH, KEY BOARD (WITH LED) (MENU)
(C5005)
LSW904 1-771-476-11 SWITCH, KEY BOARD (WITH LED) (MENU)
(C5000X/C6800X)
LSW905 1-762-620-21 SWITCH, KEY BOARD (WITH LED) (DSPL)
(C5005)
LSW905 1-771-476-11 SWITCH, KEY BOARD (WITH LED) (DSPL)
(C5000X/C6800X)
0
< LIQUID CRYSTAL DISPLAY >
LCD901 1-803-907-11 DISPLAY PANEL, LIQUID CRYSTAL (C5005)
LCD901 1-803-907-31 DISPLAY PANEL, LIQUID CRYSTAL
(C5000X/C6800X)
< DIODE >
LED901 8-719-078-21 LED SML-310PT (C5005)
LED902 8-719-078-21 LED SML-310PT (C5005)
LED903 8-719-078-21 LED SML-310PT (C5005)
LSW906 1-762-620-21 SWITCH, KEY BOARD (WITH LED) (LIST)
(C5005)
LSW906 1-771-476-11 SWITCH, KEY BOARD (WITH LED) (LIST)
(C5000X/C6800X)
LSW907 1-762-620-21 SWITCH, KEY BOARD (WITH LED) (ENTER)
(C5005)
LSW907 1-771-476-11 SWITCH, KEY BOARD (WITH LED) (ENTER)
(C5000X/C6800X)
LSW908 1-771-610-11 SWITCH, TACTILE (WITH LED) (MODE)
(C5005)
43
DISPLAY
Ref. No.
LIMIT SW
Part No.
Description
Remark
Ref. No.
Part No.
Description
Remark
LSW908 1-771-883-21 SWITCH, TACTILE (WITH LED) (MODE)
(C5000X/C6800X)
LSW910 1-771-610-11 SWITCH, TACTILE (WITH LED) (6) (C5005)
LSW910 1-771-883-21 SWITCH, TACTILE (WITH LED) (6)
(C5000X/C6800X)
LSW911 1-771-610-11 SWITCH, TACTILE (WITH LED) (5) (C5005)
LSW911 1-771-883-21 SWITCH, TACTILE (WITH LED) (5)
(C5000X/C6800X)
R926
1-216-026-11 RES-CHIP
110
5%
R927
R928
1-216-041-00 METAL CHIP
1-216-045-00 METAL CHIP
470
680
5%
5%
R933
R934
1-216-026-11 RES-CHIP
1-216-026-11 RES-CHIP
110
110
5%
5%
LSW912 1-771-610-11 SWITCH, TACTILE (WITH LED) (4) (C5005)
LSW912 1-771-883-21 SWITCH, TACTILE (WITH LED) (4)
(C5000X/C6800X)
LSW913 1-771-610-11 SWITCH, TACTILE (WITH LED) (3) (C5005)
LSW913 1-771-883-21 SWITCH, TACTILE (WITH LED) (3)
(C5000X/C6800X)
LSW914 1-771-610-11 SWITCH, TACTILE (WITH LED) (2 SHUF)
(C5005)
R936
R937
1-216-041-00 METAL CHIP
1-216-045-00 METAL CHIP
470
680
5%
5%
R951
R952
R953
1-216-040-00 RES-CHIP
1-216-021-00 METAL CHIP
1-216-049-11 RES-CHIP
430
68
1K
5%
5%
5%
1/10W
1/10W
(C5005)
1/10W
1/10W
1/10W
R954
R955
R956
R957
R958
1-216-049-11
1-216-049-11
1-216-049-11
1-216-107-00
1-216-049-11
RES-CHIP
RES-CHIP
RES-CHIP
METAL CHIP
RES-CHIP
1K
1K
1K
270K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R959
R960
R961
R970
R971
1-216-049-11
1-216-049-11
1-216-121-11
1-216-178-00
1-216-178-00
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
1K
1K
1M
150
150
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/8W
1/8W
R973
R999
1-216-178-00 RES-CHIP
1-216-295-00 SHORT
150
0
5%
1/8W
(C5000X/C6800X)
LSW914 1-771-883-21 SWITCH, TACTILE (WITH LED) (2 SHUF)
(C5000X/C6800X)
LSW915 1-771-610-11 SWITCH, TACTILE (WITH LED) (1 REP)
(C5005)
LSW915 1-771-883-21 SWITCH, TACTILE (WITH LED) (1 REP)
(C5000X/C6800X)
< TRANSISTOR >
Q901
Q902
8-729-904-66 TRANSISTOR DTD113EK-T-146 (C5005)
8-729-904-66 TRANSISTOR DTD113EK-T-146 (C5005)
1/10W
(C5005)
1/10W
1/10W
(C5005)
1/10W
1/10W
(C5005)
< RESISTOR >
< ROTARY ENCODER >
R901
R902
R903
R904
R905
1-216-647-11
1-216-647-11
1-216-647-11
1-216-651-11
1-216-655-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
680
680
680
1K
1.5K
0.5%
0.5%
0.5%
0.5%
0.5%
1/10W
1/10W
1/10W
1/10W
1/10W
R906
R907
R908
R909
R910
1-216-655-11
1-216-659-11
1-216-663-11
1-216-667-11
1-216-671-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1.5K
2.2K
3.3K
4.7K
6.8K
0.5%
0.5%
0.5%
0.5%
0.5%
1/10W
1/10W
1/10W
1/10W
1/10W
R911
R912
R913
R914
R915
1-208-806-11
1-216-647-11
1-216-647-11
1-216-647-11
1-216-651-11
RES-CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
680
680
680
1K
2%
0.5%
0.5%
0.5%
0.5%
1/10W
1/10W
1/10W
1/10W
1/10W
R916
R917
R918
R919
R920
1-216-655-11
1-216-655-11
1-216-659-11
1-216-663-11
1-216-667-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1.5K
1.5K
2.2K
3.3K
4.7K
0.5%
0.5%
0.5%
0.5%
0.5%
1/10W
1/10W
1/10W
1/10W
1/10W
R921
R922
1-216-029-00 METAL CHIP
1-216-026-11 RES-CHIP
150
110
5%
5%
R923
R924
1-216-178-00 RES-CHIP
1-216-026-11 RES-CHIP
150
110
5%
5%
R925
1-216-029-00 METAL CHIP
150
5%
1/10W
1/10W
(C5005)
1/8W
1/10W
(C5005)
1/10W
RE901
1-475-014-11 ENCODER, ROTARY
< SWITCH >
S901
44
1-771-884-21 SWITCH, TACTILE (WITH LED) (SEEK/AMS
– . m)
S902
1-771-884-21 SWITCH, TACTILE (WITH LED) (DISC/PRST +)
S903
1-771-884-21 SWITCH, TACTILE (WITH LED) (SEEK/AMS
+ M >)
S904
1-771-884-21 SWITCH, TACTILE (WITH LED) (DISC/PRST –)
*************************************************************
1-676-708-11 LIMIT SW BOARD
***************
*
< CONNECTOR >
CN13
1-770-347-21 CONNECTOR, FPC 6P
< SWITCH >
SW4
1-529-565-11 SWITCH, PUSH (1 KEY) (LIMIT)
*************************************************************
MAIN
Ref. No.
Part No.
*
*
*
A-3294-805-A MAIN BOARD, COMPLETE (C5005)
A-3294-874-A MAIN BOARD, COMPLETE (C6800X)
A-3294-877-A MAIN BOARD, COMPLETE (C5000X)
*********************
Description
Remark
*
*
*
*
3-019-565-01
3-041-157-01
3-041-174-01
3-041-261-01
7-685-793-09
BRACKET (IC)
HEAT SINK (6P)
HEAT SINK (REG)
BRACKET (TR)
SCREW +PTT 2.6X8 (S)
Ref. No.
Part No.
Description
C614
C703
C704
C705
C706
1-162-306-11
1-124-253-11
1-128-057-11
1-164-346-11
1-163-263-11
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.47uF
330uF
1uF
330PF
30%
20%
20%
Remark
C707
C708
C709
C713
C714
1-163-037-11
1-163-037-11
1-126-176-11
1-164-346-11
1-124-584-00
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
0.022uF
0.022uF
220uF
1uF
100uF
10%
10%
20%
20%
25V
25V
10V
16V
10V
C719
C720
C721
C722
C723
1-164-004-11
1-164-346-11
1-164-346-11
1-164-004-11
1-163-017-00
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
10%
1uF
1uF
0.1uF
10%
0.0047uF 10%
25V
16V
16V
25V
50V
C801
C802
C803
C804
C805
1-163-038-00
1-163-251-11
1-163-251-11
1-163-038-00
1-163-233-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
100PF
100PF
0.1uF
18PF
5%
25V
50V
50V
25V
50V
C806
C807
C808
C809
C810
1-163-233-11
1-163-222-11
1-163-222-11
1-163-809-11
1-163-133-00
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
18PF
5PF
5PF
0.047uF
470PF
5%
0.25PF
0.25PF
10%
5%
50V
50V
50V
25V
50V
C811
C812
C813
C814
C888
1-163-259-11
1-163-009-11
1-164-346-11
1-163-009-11
1-124-119-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
220PF
0.001uF
1uF
0.001uF
330uF
5%
10%
50V
50V
16V
50V
16V
C904
C905
C906
C907
C908
1-124-584-00
1-124-233-11
1-163-038-00
1-124-465-00
1-163-038-00
ELECT
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
100uF
10uF
0.1uF
0.47uF
0.1uF
C910
C913
C914
C920
C921
1-163-038-00
1-126-960-11
1-128-647-11
1-163-038-00
1-163-038-00
CERAMIC CHIP
ELECT
DOUBLE LAYERS
CERAMIC CHIP
CERAMIC CHIP
0.1uF
1uF
0.1F
0.1uF
0.1uF
C922
1-164-004-11 CERAMIC CHIP
5%
16V
50V
6.3V
16V
50V
7-685-795-09 SCREW +PTT 2.6X12 (S)
< CAPACITOR >
C101
C102
C103
C104
C110
1-163-009-11
1-163-009-11
1-163-009-11
1-164-346-11
1-124-233-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
0.001uF
0.001uF
0.001uF
1uF
10uF
10%
10%
10%
C111
C112
C123
C124
C125
1-124-233-11
1-164-346-11
1-164-346-11
1-164-346-11
1-163-133-00
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
10uF
1uF
1uF
1uF
470PF
20%
C126
C201
C202
C203
C204
1-163-251-11
1-163-009-11
1-163-009-11
1-163-009-11
1-164-346-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100PF
0.001uF
0.001uF
0.001uF
1uF
5%
10%
10%
10%
50V
50V
50V
50V
16V
C210
C211
C212
C223
C224
1-124-233-11
1-124-233-11
1-164-346-11
1-164-346-11
1-164-346-11
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
10uF
10uF
1uF
1uF
1uF
20%
20%
16V
16V
16V
16V
16V
C225
C226
C403
C404
C405
1-163-133-00
1-163-251-11
1-119-774-11
1-124-233-11
1-124-233-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
ELECT
470PF
100PF
100uF
10uF
10uF
5%
5%
20%
20%
20%
50V
50V
16V
16V
16V
C415
C426
C427
C428
C429
1-124-259-11
1-164-346-11
1-163-809-11
1-164-343-11
1-164-346-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
4.7uF
1uF
0.047uF
0.056uF
1uF
20%
16V
16V
25V
25V
16V
C431
C435
C601
C602
C603
1-135-473-11
1-126-786-11
1-163-233-11
1-163-038-00
1-124-443-00
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT
3300uF
47uF
18PF
0.1uF
100uF
20%
20%
5%
C604
C605
C607
C609
C610
1-163-038-00
1-124-233-11
1-163-021-11
1-163-009-11
1-163-251-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
10uF
0.01uF
0.001uF
100PF
20%
5%
10%
10%
50V
50V
50V
16V
16V
16V
16V
16V
16V
50V
0.1uF
5%
5%
10%
20%
20%
20%
20%
20%
10%
10V
16V
25V
50V
25V
25V
50V
5.5V
25V
25V
25V
< CONNECTOR >
20%
16V
16V
50V
25V
10V
20%
10%
10%
5%
25V
16V
50V
50V
50V
CN701
CNP501
CNP800
CNP801
1-764-617-12
1-774-701-11
1-770-520-31
1-580-907-21
PIN, CONNECTOR (PC BOARD) 30P
PIN, CONNECTOR 16P
CONNECTOR, FFC/FPC 12P
PLUG, CONNECTOR (BUS CONTROL IN)
< JACK >
CNJ600 1-793-598-11 JACK (ANTENNA)
CNP802 1-764-270-21 JACK (REMOTE IN)
45
MAIN
Ref. No.
Part No.
Description
< DIODE >
Remark
Ref. No.
D930
Part No.
Description
Remark
8-719-977-12 DIODE MA8068-M-TX
D401
D402
D404
D405
D601
8-719-988-61
8-719-991-33
8-719-422-16
8-719-988-61
8-719-921-44
DIODE
DIODE
DIODE
DIODE
DIODE
1SS355TE-17
1SS133T-77
MA8039-L-TX
1SS355TE-17
MTZJ-T-77-5.1C
D603
D701
D702
D801
D802
8-719-988-61
8-719-109-98
8-719-058-24
8-719-991-33
8-719-991-33
DIODE
DIODE
DIODE
DIODE
DIODE
1SS355TE-17
MTZJ-T-77-5.6C
RB501V-40TE-17
1SS133T-77
1SS133T-77
D803
D806
D807
D808
D809
8-719-058-24
8-719-017-94
8-719-109-97
8-719-991-33
8-719-017-94
DIODE
DIODE
DIODE
DIODE
DIODE
RB501V-40TE-17
MA8180-TX
MTZJ-T-77-6.8B
1SS133T-77
MA8180-TX
JR101
JR102
JR110
JR111
JR201
1-216-295-00
1-216-295-00
1-216-296-00
1-216-296-00
1-216-295-00
SHORT
SHORT
SHORT
SHORT
SHORT
0
0
0
0
0
D810
D811
D812
D813
D814
8-719-109-93
8-719-109-93
8-719-109-93
8-719-109-93
8-719-109-93
DIODE
DIODE
DIODE
DIODE
DIODE
MTZJ-T-77-6.2B
MTZJ-T-77-6.2B
MTZJ-T-77-6.2B
MTZJ-T-77-6.2B
MTZJ-T-77-6.2B
JR202
JR222
JR223
JR401
JR402
1-216-295-00
1-216-296-00
1-216-296-00
1-216-296-00
1-216-295-00
SHORT
SHORT
SHORT
SHORT
SHORT
0
0
0
0
0
D815
D816
D817
D818
D820
8-719-109-93
8-719-109-93
8-719-109-93
8-719-109-93
8-719-988-61
DIODE
DIODE
DIODE
DIODE
DIODE
MTZJ-T-77-6.2B
MTZJ-T-77-6.2B
MTZJ-T-77-6.2B
MTZJ-T-77-6.2B
1SS355TE-17
JR602
JR603
JR701
JR704
JR708
1-216-295-00
1-216-295-00
1-216-296-00
1-216-296-00
1-216-296-00
SHORT
SHORT
SHORT
SHORT
SHORT
0
0
0
0
0
D821
D822
D823
D901
D902
8-719-988-61
8-719-977-12
8-719-977-12
8-719-200-82
8-719-200-82
DIODE
DIODE
DIODE
DIODE
DIODE
1SS355TE-17
MA8068-M-TX
MA8068-M-TX
11ES2-TA1B
11ES2-TA1B
JR710
JR711
JR712
JR801
JR803
1-216-296-00
1-216-295-00
1-216-296-00
1-216-295-00
1-216-296-00
SHORT
SHORT
SHORT
SHORT
SHORT
0
0
0
0
0
D903
D904
D905
D906
D907
8-719-049-38
8-719-991-33
8-719-109-97
8-719-929-15
8-719-200-82
DIODE
DIODE
DIODE
DIODE
DIODE
1N5404TU
1SS133T-77
MTZJ-T-77-6.8B
MTZJ-T-77-9.1B
11ES2-TA1B
JR805
JR807
JR810
JR812
JR813
1-216-295-00
1-216-296-00
1-216-296-00
1-216-296-00
1-216-295-00
SHORT
SHORT
SHORT
SHORT
SHORT
0
0
0
0
0
D909
D910
D911
D913
D914
8-719-991-33
8-719-923-93
8-719-022-90
8-719-988-61
8-719-977-12
DIODE
DIODE
DIODE
DIODE
DIODE
1SS133T-77
MTZJ-T-77-16C
MA8160-M-TX
1SS355TE-17
MA8068-M-TX
JR816
JR817
JR888
JR901
JR902
1-216-296-00
1-216-296-00
1-216-296-00
1-216-296-00
1-216-296-00
SHORT
SHORT
SHORT
SHORT
SHORT
0
0
0
0
0
D915
D917
D918
D921
D922
8-719-914-44
8-719-991-33
8-719-929-15
8-719-079-42
8-719-079-42
DIODE
DIODE
DIODE
DIODE
DIODE
DAP202K-T-146
1SS133T-77
MTZJ-T-77-9.1B
1ZB22(TPA3)
1ZB22(TPA3)
JR911
JR914
JR916
JR917
JR920
1-216-296-00
1-216-295-00
1-216-296-00
1-216-296-00
1-216-296-00
SHORT
SHORT
SHORT
SHORT
SHORT
0
0
0
0
0
D923
D924
D925
D926
D927
8-719-079-42
8-719-079-42
8-719-079-42
8-719-079-42
8-719-079-42
DIODE
DIODE
DIODE
DIODE
DIODE
1ZB22(TPA3)
1ZB22(TPA3)
1ZB22(TPA3)
1ZB22(TPA3)
1ZB22(TPA3)
JR922
JR923
JR924
1-216-198-00 RES-CHIP
1-216-295-00 SHORT
1-216-295-00 SHORT
D928
8-719-079-42 DIODE 1ZB22(TPA3)
46
< IC >
IC101
IC701
IC801
IC802
IC901
8-759-663-88
8-759-653-27
8-759-664-64
8-759-449-89
8-759-572-12
IC
IC
IC
IC
IC
TA8268H
TDA7402TR
MN101C49KTB
BA8270F-E2
BA4903ST-V5
IC902
8-759-574-61 IC XC61AN4302MR
< JUMPER RESISTOR >
1K
0
0
< COIL >
L901
1-419-476-31 COIL, CHOKE
250uH
5%
1/8W
MAIN
Ref. No.
Part No.
Description
Remark
< JACK >
PJ400
1-794-068-11 JACK, PIN 6P (AUDIO OUT FRONT,
AUDIO OUT REAR,BUS AUDIO IN)
Ref. No.
Part No.
Description
R202
R203
R204
R212
R214
1-216-089-11
1-216-089-11
1-216-089-11
1-216-174-00
1-216-174-00
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
47K
47K
47K
100
100
5%
5%
5%
5%
5%
Remark
1/10W
1/10W
1/10W
1/8W
1/8W
R215
R216
R217
R218
R223
1-216-077-00
1-216-077-00
1-216-025-11
1-216-025-11
1-216-089-11
METAL CHIP
METAL CHIP
RES-CHIP
RES-CHIP
RES-CHIP
15K
15K
100
100
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R224
R402
R405
R406
R408
1-216-089-11
1-247-879-11
1-216-049-11
1-216-065-11
1-216-049-11
RES-CHIP
CARBON
RES-CHIP
RES-CHIP
RES-CHIP
47K
100K
1K
4.7K
1K
5%
5%
5%
5%
5%
1/10W
1/4W
1/10W
1/10W
1/10W
R409
R410
R411
R601
R602
1-216-222-00
1-216-097-11
1-216-121-00
1-216-025-11
1-216-025-11
RES-CHIP
RES-CHIP
METAL CHIP
RES-CHIP
RES-CHIP
10K
100K
1M
100
100
5%
5%
5%
5%
5%
1/8W
1/10W
1/10W
1/10W
1/10W
R603
R604
R605
R606
R607
1-216-295-00
1-216-295-00
1-216-049-11
1-216-058-00
1-216-097-11
SHORT
SHORT
RES-CHIP
RES-CHIP
RES-CHIP
0
0
1K
2.4K
100K
5%
5%
5%
1/10W
1/10W
1/10W
R701
R703
R704
R705
R706
1-216-089-11
1-216-206-00
1-216-017-11
1-216-304-11
1-216-001-00
RES-CHIP
RES-CHIP
RES-CHIP
METAL CHIP
METAL CHIP
47K
2.2K
47
3.3
10
5%
5%
5%
5%
5%
1/10W
1/8W
1/10W
1/10W
1/10W
R707
R710
R711
R712
R713
1-216-041-00
1-216-089-11
1-216-085-00
1-216-174-00
1-216-174-00
METAL CHIP
RES-CHIP
METAL CHIP
RES-CHIP
RES-CHIP
470
47K
33K
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/8W
1/8W
R714
R801
R802
R803
R804
1-216-296-00
1-208-806-11
1-208-806-11
1-216-105-11
1-216-105-11
SHORT
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
0
10K
10K
220K
220K
2%
2%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/8W
1/10W
1/4W
1/4W
1/10W
(C5005)
< TRANSISTOR >
Q101
Q102
Q201
Q202
Q401
8-729-920-31
8-729-920-31
8-729-920-31
8-729-920-31
8-729-038-55
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTC343TK-T-146
DTC343TK-T-146
DTC343TK-T-146
DTC343TK-T-146
KRA103S
Q402
Q601
Q602
Q603
Q701
8-729-038-68
8-729-049-40
8-729-049-43
8-729-038-68
8-729-038-55
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
KRC103S
STC2412G
STB1132Y
KRC103S
KRA103S
Q702
Q703
Q801
Q802
Q803
8-729-038-68
8-729-015-11
8-729-038-55
8-729-038-55
8-729-049-40
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
KRC103S
2SD1802FAST-TL
KRA103S
KRA103S
STC2412G
Q902
Q903
Q904
Q905
Q906
8-729-038-68
8-729-038-55
8-729-019-00
8-729-049-40
8-729-049-40
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
KRC103S
KRA103S
2SD2394-G
STC2412G
STC2412G
Q907
Q908
Q911
Q912
Q913
8-729-038-55
8-729-038-68
8-729-038-68
8-729-049-43
8-729-038-68
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
KRA103S
KRC103S
KRC103S
STB1132Y
KRC103S
Q914
Q915
Q916
Q919
Q920
8-729-038-55
8-729-038-55
8-729-049-40
8-729-038-68
8-729-019-00
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
KRA103S
KRA103S
STC2412G
KRC103S
2SD2394-G
Q921
Q922
8-729-049-43 TRANSISTOR STB1132Y
8-729-019-00 TRANSISTOR 2SD2394-G
< RESISTOR >
R101
R102
R103
R104
R112
1-216-064-00
1-216-089-11
1-216-089-11
1-216-089-11
1-216-025-11
METAL CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
4.3K
47K
47K
47K
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R805
R806
R807
R808
R812
1-216-246-00
1-216-097-11
1-249-417-11
1-249-417-11
1-216-089-11
RES-CHIP
RES-CHIP
CARBON
CARBON
RES-CHIP
100K
100K
1K
1K
47K
5%
5%
5%
5%
5%
R114
R115
R116
R117
R118
1-216-174-00
1-216-077-00
1-216-226-00
1-216-025-11
1-216-025-11
RES-CHIP
METAL CHIP
RES-CHIP
RES-CHIP
RES-CHIP
100
15K
15K
100
100
5%
5%
5%
5%
5%
1/8W
1/10W
1/8W
1/10W
1/10W
R812
R813
R814
1-216-295-00 SHORT
1-247-863-11 CARBON
1-216-097-11 RES-CHIP
0
22K
100K
R123
R124
R201
1-216-089-11 RES-CHIP
1-216-089-11 RES-CHIP
1-216-064-00 METAL CHIP
47K
47K
4.3K
5%
5%
5%
1/10W
1/10W
1/10W
R815
R816
1-249-417-11 CARBON
1-216-025-11 RES-CHIP
1K
100
(C5000X/C6800X)
5%
1/4W
5%
1/10W
(C5005)
5%
1/4W
5%
1/10W
R818
1-216-049-11 RES-CHIP
1K
5%
1/10W
47
MAIN
Ref. No.
RELAY
SERVO
Part No.
Description
Part No.
Description
R819
R820
R821
R822
R823
1-216-049-11
1-216-049-11
1-216-069-11
1-216-081-00
1-216-025-11
RES-CHIP
RES-CHIP
METAL CHIP
METAL CHIP
RES-CHIP
1K
1K
6.8K
22K
100
5%
5%
5%
5%
5%
Remark
1/10W
1/10W
1/10W
1/10W
1/10W
R934
R935
R936
R937
R938
1-247-810-11
1-247-810-11
1-247-810-11
1-247-810-11
1-247-810-11
CARBON
CARBON
CARBON
CARBON
CARBON
R824
R825
R826
R827
R828
1-216-097-11
1-249-429-11
1-216-025-11
1-216-025-11
1-216-073-00
RES-CHIP
CARBON
RES-CHIP
RES-CHIP
METAL CHIP
100K
10K
100
100
10K
5%
5%
5%
5%
5%
1/10W
1/4W
1/10W
1/10W
1/10W
R939
R940
1-247-810-11 CARBON
1-216-138-00 RES-CHIP
R829
R830
R831
R832
R833
1-247-807-11
1-247-807-11
1-216-073-00
1-216-073-00
1-216-049-11
CARBON
CARBON
METAL CHIP
METAL CHIP
RES-CHIP
100
100
10K
10K
1K
5%
5%
5%
5%
5%
1/4W
1/4W
1/10W
1/10W
1/10W
R834
R837
R838
R839
R840
1-216-049-11
1-216-049-11
1-216-049-11
1-216-025-11
1-216-025-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
1K
1K
1K
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R841
R843
R844
R845
1-216-049-11
1-216-295-00
1-216-025-11
1-216-097-11
RES-CHIP
SHORT
RES-CHIP
RES-CHIP
1K
0
100
100K
R846
1-216-089-11 RES-CHIP
5%
1/10W
(C5000X/C5005)
5%
1/10W
5%
1/10W
(C6800X)
5%
1/10W
(C6800X)
47K
Remark
130
130
130
130
130
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
130
3.3
5%
5%
1/4W
1/8W
< SWITCH >
S900
S901
SW802
1-762-638-11 SWITCH, TACTILE (RESET)
1-771-540-11 SWITCH, PUSH (1 KEY) (NOSE DET)
1-571-478-11 SWITCH, SLIDE (FREQUENCY SELECT)
(C6800X)
< THERMISTOR (POSITIVE) >
TH801
1-801-792-21 THERMISTOR, POSITIVE
< TUNER >
TU601
A-3220-738-A TUNER UNIT (TUX-020)
< VIBRATOR >
X800
1-781-822-11 VIBRATOR, CERAMIC (18.432MHz)
X801
1-567-098-41 VIBRATOR, CRYSTAL (32kHz)
*************************************************************
1-676-690-11 RELAY BOARD
************
*
R847
R852
R854
R855
R888
1-216-097-11
1-216-295-00
1-216-295-00
1-216-019-00
1-216-089-11
RES-CHIP
SHORT
SHORT
RES-CHIP
RES-CHIP
100K
0
0
56
47K
5%
5%
1/10W
1/10W
R901
R902
R903
R904
R905
1-216-246-00
1-216-049-11
1-216-027-00
1-216-085-00
1-216-025-11
RES-CHIP
RES-CHIP
METAL CHIP
METAL CHIP
RES-CHIP
100K
1K
120
33K
100
5%
5%
5%
5%
5%
1/8W
1/10W
1/10W
1/10W
1/10W
R907
R909
R910
R912
R914
1-216-057-00
1-216-044-00
1-216-097-11
1-216-097-11
1-216-089-11
METAL CHIP
METAL CHIP
RES-CHIP
RES-CHIP
RES-CHIP
2.2K
620
100K
100K
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R915
R917
R918
R920
R925
1-216-079-00
1-216-105-11
1-216-206-00
1-216-097-11
1-216-059-00
METAL CHIP
RES-CHIP
RES-CHIP
RES-CHIP
METAL CHIP
18K
220K
2.2K
100K
2.7K
5%
5%
5%
5%
5%
1/10W
1/10W
1/8W
1/10W
1/10W
R926
R928
R929
R930
R931
1-216-097-11
1-216-043-11
1-216-043-11
1-216-097-11
1-216-073-00
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
METAL CHIP
100K
560
560
100K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
C101
C103
C104
C106
C107
1-135-259-11
1-104-609-11
1-135-259-11
1-164-360-11
1-115-156-11
TANTAL. CHIP
ELECT CHIP
TANTAL. CHIP
CERAMIC CHIP
CERAMIC CHIP
10uF
100uF
10uF
0.1uF
1uF
R933
1-216-083-00 METAL CHIP
27K
5%
1/10W
C108
1-162-974-11 CERAMIC CHIP
0.01uF
48
5%
Ref. No.
1/10W
< CONNECTOR >
CNP902 1-794-064-11 SOCKET, CONNECTOR 14P
CNP903 1-792-173-11 CABLE, FLAT (FFC) 12P
< DIODE >
LED905 8-719-033-14 LED CL-170PG-CD-T (CD WINDOW)
< SWITCH >
LSW916 1-771-609-11 SWITCH, TACTILE (WITH LED) (Z)
< RESISTOR >
R930
1-216-037-00 METAL CHIP
330
5%
1/10W
*************************************************************
A-3294-809-A SERVO BOARD, COMPLETE
***********************
*
< CAPACITOR >
20%
20%
20%
6.3V
4V
6.3V
16V
10V
50V
SERVO
Ref. No.
Part No.
Description
C109
C111
C115
C116
C117
1-162-915-11
1-104-852-11
1-164-733-11
1-165-128-11
1-162-962-11
CERAMIC CHIP
TANTAL. CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
10PF
22uF
820PF
0.22uF
470PF
Remark
C118
C127
C301
C302
C303
1-164-360-11
1-104-851-11
1-126-393-11
1-164-360-11
1-164-227-11
CERAMIC CHIP
TANTAL. CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
10uF
33uF
0.1uF
0.022uF
C304
C305
C306
C307
C308
1-164-227-11
1-162-962-11
1-162-962-11
1-162-962-11
1-162-962-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
C309
C310
C311
C312
C501
1-164-227-11
1-125-838-11
1-164-677-11
1-164-360-11
1-126-391-11
C502
C504
C505
C506
C507
0.5PF
20%
10%
10%
50V
10V
50V
16V
50V
10%
16V
10V
10V
16V
25V
0.022uF
470PF
470PF
470PF
470PF
10%
10%
10%
10%
10%
25V
50V
50V
50V
50V
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
0.022uF
2.2uF
0.033uF
0.1uF
47uF
10%
10%
10%
20%
25V
6.3V
16V
16V
6.3V
1-162-965-11
1-162-967-11
1-165-176-11
1-107-823-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.0015uF
0.0033uF
0.047uF
0.47uF
0.1uF
10%
10%
10%
10%
10%
50V
50V
16V
16V
16V
C508
C509
C510
C511
C512
1-164-230-11
1-164-360-11
1-164-217-11
1-164-217-11
1-162-963-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
220PF
0.1uF
150PF
150PF
680PF
5%
50V
16V
50V
50V
50V
C513
C514
C515
C517
C518
1-162-963-11
1-126-391-11
1-164-360-11
1-164-360-11
1-164-360-11
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
680PF
47uF
0.1uF
0.1uF
0.1uF
C519
C520
C521
C522
C550
1-164-360-11
1-164-360-11
1-164-360-11
1-164-360-11
1-164-360-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
16V
16V
16V
16V
16V
C553
C554
1-164-360-11 CERAMIC CHIP
1-164-360-11 CERAMIC CHIP
0.1uF
0.1uF
16V
16V
20%
20%
5%
5%
10%
10%
20%
50V
6.3V
16V
16V
16V
Ref. No.
FB503
Part No.
Description
Remark
1-500-445-21 FERRITE BEAD INDUCTOR
< IC >
IC1
IC5
IC7
IC501
8-752-095-36
8-752-914-87
8-759-653-67
8-752-392-04
IC
IC
IC
IC
CXA2596M-T6
CXP84640-072Q
LA6556
CXD2598Q
< JUMPER RESISTOR >
JR501
JR505
JR506
JR507
1-216-295-00
1-216-864-11
1-216-864-11
1-216-295-00
SHORT
METAL CHIP
METAL CHIP
SHORT
0
0
0
0
5%
5%
1/16W
1/16W
< TRANSISTOR >
Q101
8-729-904-87 TRANSISTOR 2SB1197K-T-146-R
< RESISTOR >
R101
R102
R103
R104
R105
1-216-847-11
1-216-847-11
1-216-158-00
1-216-857-11
1-216-833-11
METAL CHIP
METAL CHIP
RES-CHIP
METAL CHIP
RES-CHIP
150K
150K
22
1M
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/8W
1/16W
1/16W
R106
R107
R108
R110
R111
1-216-857-11
1-216-829-11
1-216-829-11
1-216-837-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
RES-CHIP
1M
4.7K
4.7K
22K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R113
R116
R122
R123
R126
1-216-839-11
1-216-845-11
1-216-845-11
1-216-839-11
1-216-842-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
33K
100K
100K
33K
56K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R127
R213
R301
R302
R303
1-216-821-11
1-216-821-11
1-216-843-11
1-216-839-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
68K
33K
1K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R304
R306
R307
R308
R309
1-216-839-11
1-216-833-11
1-216-833-11
1-216-833-11
1-216-833-11
METAL CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
33K
10K
10K
10K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R310
R311
R312
R313
R314
1-216-833-11
1-216-833-11
1-216-845-11
1-216-842-11
1-216-842-11
RES-CHIP
RES-CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10K
100K
56K
56K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R315
R316
R317
R318
R319
1-216-842-11
1-216-842-11
1-216-838-11
1-216-842-11
1-216-842-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
56K
56K
27K
56K
56K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
< CONNECTOR >
CN1
CN2
CN3
1-764-616-12 HOUSING, CONNECTOR (PC BOARD) 30P
1-794-153-21 CONNECTOR, FPC (ZIF)16P
1-770-347-21 CONNECTOR, FPC 6P
< FERRITE BEAD >
FB101
FB102
FB103
FB501
1-216-295-00
1-216-295-00
1-216-295-00
1-216-295-00
SHORT
SHORT
SHORT
SHORT
0
0
0
0
49
SERVO
Ref. No.
Part No.
Description
R321
R322
R501
R503
R504
1-216-846-11
1-216-835-11
1-216-833-11
1-216-845-11
1-216-857-11
METAL CHIP
METAL CHIP
RES-CHIP
METAL CHIP
METAL CHIP
120K
15K
10K
100K
1M
5%
5%
5%
5%
5%
Remark
1/16W
1/16W
1/16W
1/16W
1/16W
R505
R506
R507
R511
R513
1-216-839-11
1-216-845-11
1-216-827-11
1-216-845-11
1-216-827-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
33K
100K
3.3K
100K
3.3K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R516
R517
R518
R519
R520
1-216-845-11
1-216-837-11
1-216-834-11
1-216-834-11
1-216-834-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
22K
12K
12K
12K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R521
R522
R523
R524
R526
1-216-834-11
1-216-834-11
1-216-834-11
1-216-845-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
12K
12K
12K
100K
100K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R527
R531
R532
R533
R535
1-216-845-11
1-216-809-11
1-216-845-11
1-216-845-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
100
100K
100K
100K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R551
R552
R553
R554
R555
1-216-841-11
1-216-841-11
1-216-845-11
1-216-845-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
47K
100K
100K
100K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R558
R560
R563
R564
R568
1-216-864-11
1-216-809-11
1-216-809-11
1-216-845-11
1-216-837-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
100
100
100K
22K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R569
R570
R572
R590
R594
1-216-809-11
1-216-821-11
1-216-809-11
1-216-845-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
1K
100
100K
100K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R595
R599
1-216-845-11 METAL CHIP
1-216-821-11 METAL CHIP
100K
1K
5%
5%
1/16W
1/16W
Ref. No.
Part No.
Description
Remark
MISCELLANEOUS
***************
9
* 201
206
207
0 210
1-792-194-21
X-3378-480-1
1-676-707-11
1-677-182-11
8-820-103-03
CORD (WITH CONNECTOR) (POWER)
CHASSIS (OP) ASSY (INCLUDING M901)
PICK-UP FLEXIBLE BOARD
MOTOR FLEXIBLE BOARD
PICK-UP, OPTICAL KSS-720A/K1RP
F901
1-532-877-11 FUSE (BLADE TYPE) (AUTO FUSE) 10A
M902
A-3301-985-A MOTOR ASSY, SLED (SLED)
M903
A-3301-978-A MOTOR SUB ASSY, LO (LOADING)
*************************************************************
ACCESSORIES & PACKING MATERIALS
********************************
3-043-278-11 MANUAL, INSTRUCTION, INSTALL (ENGLISH,
FRENCH) (C5000X/C5005)
3-043-279-11 MANUAL, INSTRUCTION (ENGLISH)
(C5000X/C5005)
3-043-279-21 MANUAL, INSTRUCTION (FRENCH) (CND)
3-044-888-11 MANUAL, INSTRUCTION, INSTALL (ENGLISH,
SPANISH,TRADITIONAL CHINESE)
(C6800X)
3-044-889-11 MANUAL, INSTRUCTION (ENGLISH,SPANISH,
TRADITIONAL CHINESE) (C6800X)
X-3378-390-1 CASE ASSY (for FRONT PANEL)
*************************************************************
**************
HARDWARE LIST
**************
#1
#2
#3
#4
#5
7-685-793-09
7-685-792-09
7-685-795-09
7-685-106-19
7-621-772-20
SCREW +PTT 2.6X8 (S)
SCREW +PTT 2.6X6 (S)
SCREW +PTT 2.6X12 (S)
SCREW +P 2X10 TYPE 2 NON-SLIT
SCREW +B 2X5
#6
7-627-552-87 SCREW, PRECISION +P 1.7X2.2
#7
7-628-253-00 SCREW +PS 2X4
#8
7-627-553-37 SCREW, PRECISION +P 2X3 TYPE 3
#9
7-627-553-17 SCREW, PRECISION +P 2X2 TYPE 3
#10
7-627-850-28 SCREW, PRECISION +P 1.4X3
*************************************************************
< SWITCH >
SW1
1-762-944-12 SWITCH, DETECTION (SMALL TYPE) (DOWN)
< VIBRATOR >
X1
1-781-758-21 VIBRATOR, CERAMIC (CHIP TYPE) (10MHz)
X2
1-781-759-21 VIBRATOR, CERAMIC (CHIP TYPE) (16MHz)
*************************************************************
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
50
Les composants identifiés par une
marque 0 sont critiques pour la
sécurité.
Ne les remplacer que par une piéce
portant le numéro spécifié.
Ref. No.
Part No.
Description
Remark
PARTS FOR INSTALLATION AND CONNECTIONS
**************************************
251
252
253
254
255
3-014-370-21 FRAME, FITTING
3-916-012-01 BRACKET (ND), FITTING ASSIST
(C5000X/C5005)
7-682-160-01 SCREW +P 4X6 (C5000X/C5005)
X-3368-725-1 SCREW ASSY, FITTING (C5000X/C5005)
3-041-027-01 COLLAR
256
257
258
259
X-3366-405-1
3-030-929-02
3-934-325-01
1-792-194-21
SCREW ASSY (EXP), FITTING (C6800X)
SPRING, FITTING
SCREW (+K 5X8 TP)
CORD (WITH CONNECTOR) (POWER)
254
251
252
255
258
253
256
257
259
51
CDX-C5000X/C5005/C6800X
9-870-075-11
Sony Corporation
Mobile Electronics Division Company
52
2000B047035-1
Printed in Singapore ©2000. 2
Published by General Engineering Dept.