Download SERVICE MANUAL - MiniDisc Community Page

MDX-C8500R/C8500X
SERVICE MANUAL
US Model
MDX-C8500X
Ver 1.1 2001.05
AEP Model
UK Model
MDX-C8500R
Photo: MDX-C8500X
Model Name Using Similar Mechanism
NEW
Base Mechanism Type
MG-164NV-138
Optical Pick-up Name
KMS-241C/J1NP
SPECIFICATIONS
AUDIO POWER SPECIFICATIONS (MDX-C8500X)
POWER OUTPUT AND TOTAL HARMONIC DISTORTION
19 watts per channel minimum continuous average power into 4ohms, 4
channels driven from 10 Hz to 20 kHz with no more than 1% total harmonic
distortion.
AM (MDX-C8500X)
Other specifications
Tuning range
Antenna terminal
Intermediate frequency
Sensitivity
Disc player section
MD player
Signal-to-noise ratio
Frequency response
Wow and flutter
90 dB
10 – 20,000 Hz
Below measurable limit
Laser Diode Properties
Material
Wavelength
Emission Duration
Laser output power
GaAlAs
780 nm
Continuous
Less than 44.6 W*
530 – 1,710 kHz
External antenna connector
10.7 MHz/450 kHz
30 µV
(MDX-C8500R)
Power amplifier section
* This output is the value measured at a distance
of 200 mm from the objective lens surface on
the Optical Pick-up Block.
Outputs
Speaker outputs
(sure seal connectors)
Speaker impedance
4 – 8 ohms
Maximum power output 50 W × 4 (at 4 ohms)
Tuner section
– Continued on next page –
FM
Tuning range
87.5 – 107.9 MHz
(MDX-C8500X)
87.5 – 108.0 MHz
(MDX-C8500R)
Antenna terminal
External antenna connector
Intermediate frequency 10.7 MHz/450 kHz
Usable sensitivity
8 dBf
Selectivity
75 dB at 400 kHz
Signal-to-noise ratio
66 dB (stereo),
72 dB (mono)
Harmonic distortion at 1 kHz
0.6 % (stereo),
0.3 % (mono)
Separation
35 dB at 1 kHz
Frequency response
30 – 15,000 Hz
FM/AM(MW/LW) MINIDISC PLAYER
9-870-096-12
Sony Corporation
2001E0500-1
C 2001.5
e Vehicle Company
Shinagawa Tec Service Manual Production Group
TABLE OF CONTENTS
General
Outputs
Power requirements
Dimensions
Mounting dimensions
Mass
Supplied accessories
Audio outputs
Power antenna relay
control lead
Power amplifier control
lead
Telephone ATT control
lead
12 V DC car battery
(negative ground)
Approx. 178 × 50 × 183 mm
(7 1/8 × 2 × 7 1/8 in.)
(w/h/d)
Approx. 182 × 53 × 162 mm
(7 1/4 × 2 1/8 × 6 3/8 in.)
(w/h/d)
Approx. 1.2 kg (2 lb 10 oz)
Card remote commander
RM-X91 (MDX-C8500X)
Parts for installation and
connections (1 set)
Front panel case (1)
U.S. and foreign patents licensed from Dolby
laboratories Licensing Corporation.
Design and specifications are subject to change
without notice.
1.
SERVICING NOTES ............................................... 3
2.
GENERAL
Location of Controls .......................................................
Setting the Clock .............................................................
Installation .......................................................................
Connections .....................................................................
3.
DISASSEMBLY ......................................................... 11
4.
ELECTRICAL ADJUSTMENTS
Test Mode ........................................................................ 18
MD Section ..................................................................... 18
Tuner Section .................................................................. 18
5.
DIAGRAMS
5-1.
5-2.
5-3.
5-4.
5-13.
5-14.
5-15.
5-16.
5-17.
5-18.
5-19.
5-20.
5-21.
5.22.
5-23.
Block Diagram – SERVO Section – ...............................
Block Diagram – TUNER Section – ..............................
Block Diagram – MAIN Section – .................................
Block Diagram
– DISPLAY/KEY CONTROL Section – ........................
Block Diagram
– BUS CONTROL/POWER SUPPLY Section – ...........
Note for Printed Wiring Boards and
Schematic Diagrams .......................................................
Printed Wiring Boards
– SERVO Board (Component Side)/
SENSOR Board – ............................................................
Printed Wiring Board
– SERVO Board (Conductor Side) – ..............................
Schematic Diagram
– SERVO Board (1/2)/ SENSOR Board– ......................
Schematic Diagram – SERVO Board (2/2) – .................
Printed Wiring Board
– MAIN Board (Component Side) – ..............................
Printed Wiring Board
– MAIN Board (Conductor Side) – ................................
Schematic Diagram – MAIN Board (1/4) – ...................
Schematic Diagram – MAIN Board (2/4) – ...................
Schematic Diagram – MAIN Board (3/4) – ...................
Schematic Diagram – MAIN Board (4/4) – ...................
Printed Wiring Board – DSO Board – ............................
Schematic Diagram – DSO Board – ...............................
Printed Wiring Board – SUB Board – ............................
Schematic Diagram – SUB Board – ...............................
Printed Wiring Board – KEY Board – ............................
Schematic Diagram – KEY Board – ..............................
IC Pin Function Description ...........................................
6.
EXPLODED VIEWS ................................................ 59
7.
ELECTRICAL PARTS LIST ............................... 63
5-5.
5-6.
5-7.
5-8.
5-9.
5-10.
5-11.
5-12.
2
4
4
5
7
19
20
21
22
23
24
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
47
SECTION 1
SERVICING NOTES
NOTES ON HANDLING THE OPTICAL PICK-UP
BLOCK OR BASE UNIT
The laser diode in the optical pick-up block may suffer electrostatic break-down because of the potential difference generated
by the charged electrostatic load, etc. on clothing and the human
body.
During repair, pay attention to electrostatic break-down and also
use the procedure in the printed matter which is included in the
repair parts.
The flexible board is easily damaged and should be handled with
care.
• Model Identification
There are three types of main board in according of destination
for MDX-C8500R.
– MAIN BOARD (Component Side)
NOTES ON LASER DIODE EMISSION CHECK
Never look into the laser diode emission from right avove when
checking it for adustment. It is feared that you will lose your sight.
R502
NOTES ON HANDLING THE OPTICAL PICK-UP BLOCK
(KMS-241C/J1NP)
The laser diode in the optical pick-up block may suffer electrostatic break-down easily. When handling it, perform soldering
bridge to the laser-tap on the flexible board. Also perform m easures
against electrostatic break-down sufficiently before the operation.
The flexible board is easily damaged and should be handled with
care.
R503
IC502
R502
R503
a
×
TYPE B
×
a
TYPE C
a
a
TYPE A
Type A, B and C can be identified by its model number label at
the buttom of the set.
– SPECIFICATION LABEL –
laser-tap
TYPE A
OPTICAL PICK-UP FLEXIBLE BOARD
Notes on chip component replacement
• Never reuse a disconnected chip component.
• Notice that the minus side of a tantalum capacitor may be damaged by heat.
Flexible Circuit Board Repairing
• Keep the temperature of the soldering iron around 270 ˚C during repairing.
• Do not touch the soldering iron on the same conductor of the
circuit board (within 3 times).
• Be careful not to apply force on the conductor when soldering
or unsoldering.
TYPE B
CAUTION
Use of controls or adjustments or performance of procedures
other than those specified herein may result in hazardous radiation exposure.
TYPE C
SAFETY-RELATED COMPONENT WARNING!!
COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED
LINE WITH MARK 0 ON THE SCHEMATIC DIAGRAMS
AND IN THE PARTS LIST ARE CRITICAL TO SAFE
OPERATION. REPLACE THESE COMPONENTS WITH
SONY PARTS WHOSE PART NUMBERS APPEAR AS
SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY.
3
SECTION 2
GENERAL
This section is extracted from
instruction manual.
Setting the clock
The clock uses a 12-hour digital indication.
Example: To set the clock to 10:08
1
Press (MENU), then press either side of
(DISC/PRST) repeatedly until “Clock”
appears.
1 Press (ENTER).
The hour indication flashes.
2 Press either side of (DISC/PRST) to set
the hour.
3 Press (+) side of (SEEK/AMS).
The minute indication flashes.
4 Press either side of (DISC/PRST) to set
the minute.
2
Press (ENTER).
The clock starts.
After the clock setting is completed, the
display returns to normal playback mode.
Tip
You can set the clock automatically with the RDS
feature (see page 24). (MDX-C8500R)
Note
In the initial setting, the clock indication appears
while the unit is turned off.
When you select the “on” setting of the “D.Info”
item (page 29), you can see the clock indication in
the upper part of the display while you are
enjoying any source.
Location of controls (MDX-C8500X)
Card remote commander RM-X91
OPEN/CLOSE
OFF
MENU
The corresponding buttons of the card
remote commander control the same
functions as those on this unit.
1 OFF button
DISC
LIST
SEEK
SEEK
2 MENU button
3 SOURCE button
4 SEEK/AMS (cursor </,) buttons
SOURCE
5 SOUND button
SOUND
DISC
ENTER
DSPL
ATT
MODE
VOL
6 DSPL button
7 ATT button
8 LIST button
9 DISC/PRST (cursor M/m) buttons
0 ENTER button
qa MODE button
qs VOL buttons
4
5
6
7
8
(MDX-C8500R)
9
(MDX-C8500X)
Connection example
Exemple de connection
Ejemplo de conexiones
* RCA pin cord (not supplied)
Cordon à broche RCA (non fourni)
Cable con pines RCA (no suministrado)
*
Source selector
(not supplied)
Sélecteur de source
(non fourni)
Selector de fuente
(no suministrado)
Supplied to the CD/MD changer
Fourni avec le changeur de CD/MD
Suministrado con el cambiador de CD/MD
XA-C30
Supplied to XA-C30
Fourni avec le XA-C30
Suministrado con el XA-C30
BUS AUDIO IN
AUDIO OUT FRONT
*
SUB OUT (MONO)
REMOTE IN
Rotary commander RM-X4S (not supplied)
Satellite de commande RM-X4S (non fourni)
Mando rotativo RM-X4S (no suministrado)
from car antenna
de l’antenne de la voiture
de la antena del automóvil
AUDIO OUT REAR
BUS
CONTROL IN
8
AMP REM
To AMP REMOTE IN of an optional power amplifier.
This connection is only for amplifiers. Connecting any
other system may damage the unit.
Pour effectuer le raccordement à AMP REMOTE IN de
l’amplificateur de puissance en option.
Cette connexion s’applique uniquement aux
amplificateurs. Le branchement de tout autre système
risque d’endommager l’appareil.
Para conectar a AMP REMOTE IN del amplificador de
potencia opcional.
Esta conexión es sólo para amplificadores.
La conexión de cualquier otro sistema puede dañar la
unidad.
Left
Gauche
Izquierdo
Right
Droit
Derecho
Insert with the cord upwards.
Insérez avec le câble vers le haut.
Insertar con el cable hacia arriba.
Blue/white striped
Rayé bleu/blanc
Con raya azul/blanca
Max. supply current 0.3 A
Courant max. fourni 0,3 A
Corriente máx. de
alimentación de 0,3 A
to the power antenna control lead or power supply lead of
antenna booster amplifier
Notes
• It is not necessary to connect this lead if there is no power
antenna or antenna booster, or with a manually-operated
telescopic antenna.
• When your car has a built-in FM/AM antenna in the rear/side
glass, see “Notes on the control and power supply leads.”
Fuse (10 A)
Fusible (10 A)
Fusible (10 A)
Blue
Bleu
Azul
ANTREM
Max. supply current 0.1 A
Courant max. fourni 0,1 A
Corriente máx. de alimentación de 0,1 A
al cable de control de la antena motorizada o al cable de
fuente de alimentación del amplificador de antena
Notas
• Si no se dispone de antena motorizada ni de amplificador de
antena, o se utiliza una antena telescópica accionada
manualmente, no será necesario conectar este cable.
• Si el automóvil incorpora una antena de FM/AM en el cristal
trasero/lateral, consulte “Notas sobre los cables de control y
de fuente de alimentación”.
White
Blanc
Blanco
White/black striped
Rayé blanc/noir
Con raya blanco/negro
to the +12 V power terminal which is energized in the
accessory position of the ignition key switch
Notes
• If there is no accessory position, connect to the +12 V power
(battery) terminal which is energized at all times.
Be sure to connect the black ground to it first.
• When your car has a built-in FM/AM antenna in the rear/side
glass, see “Notes on the control and power supply leads.”
Grey
Gris
Gris
Gray/black striped
Rayé gris/noir
Con raya gris/negro
à la borne +12 V qui est alimentée quand la clé de contact
est sur la position accessoires
Remarques
• S’il n’y a pas de position accessoires, raccordez la borne
d’alimentation (batterie) +12 V qui est en permanence sous
tension.
Veillez à raccorder le fil noir en premier lieu.
• Si votre voiture est équipée d’une antenne FM/AM intégrée
dans la vitre arrière/latérale, voir les “Remarques sur les
câbles de commande et d’alimentation”.
Red
Rouge
Rojo
Left
Gauche
Izquierdo
Right
Droit
Derecho
to a metal surface of the car
First connect the black ground lead, then connect the
yellow and red power input reads.
vers un point métallique de la voiture
Branchez d‘abord le fil de masse noir et, ensuite, les fils
d‘entrée d‘alimentation jaune et rouge.
a un punto metálico del automóvil
En primer lugar conecte el conductor de puesta a masa
negro y, a continuación, los cables de entrada de
alimentación amarillo y rojo.
10
vers le fil de commande de l‘antenne électrique ou le fil
d‘alimentation de l‘amplificateur d‘antenne
Remarques
• Il n’est pas nécessaire de raccorder ce fil s’il n’y a pas
d’antenne électrique ni d’amplificateur d’antenne, ou avec
une antenne télescopique manuelle.
• Si votre voiture est équipée d’une antenne FM/AM intégrée
dans la vitre arrière/latérale, voir les “Remarques sur les
câbles de commande et d’alimentation”.
Green
Vert
Verde
al terminal de alimentación de +12 V que se active en la
posición auxiliar de la llave de encendido
Notas
• Si no existe posición auxiliar, realice la conexión al terminal
de alimentación (batería) de +12 V que reciba energía
permanentemente.
Asegúrese de conectar primero a este terminal el conductor
de puesta a masa negro.
• Si el automóvil incorpora una antena de recepción de FM/
AM en el cristal trasero/lateral, consulte “Notas sobre los
cables de control y de fuente de alimentación”.
Green/black striped
Rayé vert/noir
Con raya verde/negro
Purple
Mauve
Púrpura
Purple/black striped
Rayé mauve/noir
Con raya púrpura/negro
Black
Noir
Negro
Light blue
Bleu ciel
Azul celeste
Yellow
Jaune
Amarillo
ATT
to the interface cable of a car telephone
vers le cordon de liaison d’un téléphone de voiture
al cable de interfaz de un teléfono para automóvil
to the +12 V power terminal which is energized at all times
Be sure to connect the black ground to it first.
à la borne +12 V qui est alimentée en permanence
Raccordez d‘abord le fil de masse noir.
al terminal de alimentación de +12 V que esté
permanentemente energizado
Asegúrese de conectar primero a este terminal el conductor de
puesta a masa negro.
SECTION 3
DISASSEMBLY
Note: Follow the disassembly procedure in the numerical order given.
SUB PANEL ASS’Y
1 screw
(PTT2.6 × 6)
2 cover
4 two claws
6 sub panel ass’y
3 screw
(PTT2.6 × 8)
4 claw
3 two screws
(PTT2.6 × 8)
5 connector (CN752)
3 screw
(PTT2.6 × 8)
MECHANISM DECK (MG-164NV-138)
3 two screws
(PTT2.6 × 10)
4 bracket (MD)
5 mechanism deck
(MG-164NV-138)
1 screw
(PTT2.6 × 6)
2 connector
(CN101)
1 screw
(PTT2.6 × 6)
11
SERVO BOARD
2 two screws
(BVTT2 × 4)
2 two screws
(BVTT2 × 4)
3 servo board
1 sensor flexible board
(CN102)
1 flexible board
(CN103)
MAIN BOARD
4 cord (with connector) (sub out)
5 two screws
(PTT2.6 × 10)
3 screw (PTT2.6 × 10)
2 three ground point
screws
1 connector (CN301)
6 main board
12
MD COVER ASS’Y
1 four screws
(B2 × 3)
3 MD cover ass’y
shaft (MD cover guide)
cassette holder
A
2 Pushing the Cassette Holder in the direction of arrow A with a
screwdriver, etc., disengage the Shaft (MD Cover Guide) from
the slot in the MD Cover Assy.
Note: Take care not to scratch the optiocal Pick-up when pushing
the Cassette Holder with a screwdriver. etc.
HEAT SINK
1 four screws
(PTT2.6 × 8)
2 two screws
(PTT2.6 × 12)
3 heat sink
1 three screws
(PTT2.6 × 8)
13
FLOAT BLOCK
3 Pushing arrow A part, raise the float block
up ward at the front to release a lock.
1 tension spring (float B)
A
float block
lever (lock R)
lever (lock L)
1 tension spring (float B)
2 two tension springs (float F)
LO MOTOR ASS’Y (LOADING) (M903)
4 Remove the bracket (LO)
in the direction of arrow A.
A
1 Remove solders of motor (M903)
5 LO motor ass’y (loading)
(M903)
2 tension spring (rack)
3 claw
bracket (LO)
– bottom view –
14
LEVER (LE) ASS’Y
2 stopper washer
2 lever (LE) ass’y
3 roller (gear E)
1
HOLDER ASS’Y
4 Remove the holder ass’y in the
direction of the arrow.
2 type-E stopring 1.5
1 spring (chucking)
2 type-E stopring 1.5
2 type-E stopring 1.5
3 lever (lock R)
3 lever (lock L)
1 spring (chucking)
2 type-E stopring 1.5
15
CHUCKING ARM ASS’Y
1 Remove the chucking arm ass’y
in the direction of the arrow.
holder ass’y
OPTICAL PICK-UP (KMS-241C/J1NP)
4 screw
(B2 × 3)
6 bearing (SL)
5 feed screw ass’y
7 optical pick-up
(KMS-241C/J1NP)
1 two screws
(K2 × 3)
2 guide shaft (OPT L)
16
3 screw
(K2 × 3)
SL MOTOR ASS’Y (SLED) (M902), SP MOTOR ASS’Y (SPINDLE) (M901)
4 screw
(P1.7 × 1.8)
9 two screws
(P1.7 × 1.8)
5 bracket (SL)
2 two screws
(2 × 8)
6 SL motor ass’y
(sled) (M902)
0 bracket (SP)
7 screw
(B2 × 3)
qa SP motor ass’y
(spindle) (M901)
3 sensor board
8 base (SL)
1 Remove solders of motors
(M901, M902)
17
SECTION 4
ELECTRICAL ADJUSTMENTS
TEST MODE
This set have the test mode function.
<Set the Test Mode>
1. Turn ON the regulated power supply. (The clock is displayed)
Note: Press the
2.
3.
4.
5.
[OFF]
button, if the clock is not displayed.
Push the preset [4] button.
Push the preset [5] button.
Press the preset [1] button for more than two seconds.
Then the display indicates all lights, the test mode is set.
<Release the Test mode>
1. Push the [OFF] button.
MD SECTION
MD section adjustments are done automatically in this set.
TUNER SECTION
Tuner section adjustments are done automatically in this set.
18
MDX-C8500R/C8500X
SECTION 5
DIAGRAMS
15
TX
BLOCK DIAGRAM – SERVO Section –
AGCI
RF
RF AGC
& EQ
55
38
(Page 21)
ASYI
DADT
COMPARATOR
RFI
DADT, BCK, LRCK, 512FS
24
EQ
33
WBL
3T
F
TEMP
D-RAM
PEAK
B
XBCK
LRCK
FS256
26 25 27
AUX
B.P.F.
PEAK &
BOTTOM
BOTM
ADIN
ADFG
OSCI
CLOCK
GENERATOR
37
OSCO
E
8
9
F
FE
FOCUS
ERROR AMP
E
F
TE
TRACKING
ERROR AMP
I-V
AMP
SE
D0 – D3
35
34
79
F0CNT
CPU
INTERFACE
SPINDLE
SERVO
26
28
94 93 10
12
11
14
9 8
MONITOR
CONTROL
5 6 7
A00 – A09
ABCD
ABCD
AMP
78
32
MNT0
MNT1
MNT2
MNT3
C
D
I-V
AMP
30
SWDT
SCLK
XLAT
DETECTOR
29
B.P.F.
SENS
SRDT
E
A
B
C
D
INTERNAL BUS
XINT
4
5
6
7
SUBCODE
PROCESSOR
ADIP
DEMODULATOR/
DECODER
SQSY
A
ADFM
AT
AMP
XRST
DQSY
J
SPRD
A
SPFD
D
ADFG
I
B
1 2 3 4
WBL
3T
EQ
COMMAND
PD
10
V-I
CONVERTER
PD
12
3 1
LEVEL SHIFT
IC502
6
12
XOE
XWE
XRAS
XCAS
13
1
3
5
13
LEVEL SHIFT
IC503
4 2
41
45
44
42
22
3
4
23
20
OE
WE
RAS
CAS
12
2
4
6
LD
11
LD/PD
AMP
512FS OSC
IC304
SWDT
SCLK
XLAT
PD
APC
5
SERIAL/
PARALLEL
CONVERTER,
DECODER
F0CNT
ILCC
APCREF
AUTOMATIC
POWER
CONTROL
Q302
17
D-RAM
IC307
16 17 18
OPTICAL PICK-UP BLOCK
(KMS-241C)
FOK
SHOCK
XBUSY
SLOCK
LASER DIODE
16
36
WBL
C
A
1, 2, 24, 25
D0 – D3
40
DIN
21
DOUT
22
9 – 12, 14 – 18, 5
A0 – A9
46
DIGITAL
AUDIO
INTERFACE
47, 46, 48, 49
RFO
SAMPLING
RATE
CONVERTER
512FS
MORFI
RF AMP
J
52
ASYO
DIGITAL SIGNAL PROCESSOR,
EFM/ACIRC ENCODER/DECODER,
SHOCK PROOF MEMORY CONTROLLER,
ATRAC ENCODER/DECODER, 2M BIT D-RAM
IC301 (1/2)
32 – 29, 34 – 38, 43
2
I
PLL
: MD PLAY
23
BCK
LRCK
1
J
MORFO
I
ADDT
ATRAC
ENCODER/DECODER
FILTER
FILI
59
PCO
58
CLTV
61
FILO
60
51
• SIGNAL PATH
EFMO
RF AMP,
FOCUS/TRACKING ERROR AMP
IC302
48 47
IC301 (1/2)
SHOCK PROOF
MEMORY CONTROLLER
100
EFM/ACIRC
ENCODER/DECODER
5-1.
+3.3V
FOCUS/TRACKING COIL DRIVE,
SPINDLE/SLED MOTOR DRIVE
IC303
(Page 21)
EMPHASIS
FCS+
(FOCUS)
(TRACKING)
21 OUT1F
23 OUT1R
IN2F 29
IN2R 30
IN1F 19
IN1R 18
SFDR
92
SRDR
91
FFDR
88
FRDR
89
IN3F 14
IN3R 15
TFDR
86
TRDR
85
39
66
MNT0
MNT1
MNT2
MNT3
TEMP
DEEMP
31 EXTAL
ANALOG MUX
A-MUTE 67
MD MECHANISM CONTROLLER
IC501 (1/2)
X501
10MHz
32 XTAL
XLRF
CKRF
DTRF
80
81
82
LOADING
MOTOR DRIVE
IC305
7
6
63
11
56
5
4
RIN
FIN
LOADING START/
EJECT END
OUT1 OUT2
1
7
DIGITAL SERVO
SIGNAL PROCESSOR
IC301 (2/2)
M903
(LOADING)
05
19
19
M
ON: When the disc loading start
and the disc eject completion.
MD-ATT
B
C
(Page 21)
FROM CPU
INTERFACE
AUTO
SEQUENCER
12 OUT3F
10 OUT3R
26 27 28 29
A/D CONVERTER
DIGITAL
SERVO
SIGNAL
PROCESS
FCS–
TRK+
TRK–
45 51 64
LIMIT-IN
27 OUT2F
25 OUT2R
54 52
E-SW
2-AXIS
DEVICE
M
PWM GENERATOR
M902
(SLED)
55
66 75 64 65 74 73 62 63
C-SW
AUTOMATIC
POWER
CONTROL
62
MD-SO
MD-CKO
MD-LAT
APCREF
83
59
SENS
MD-SI
13
RECP
CC-XINT
+3.3V
IC306
LOAD
SPFD
SPRD
SQSY
IN4R 3
IN4F 4
EJECT
6 OUT4F
8 OUT4R
MD-RST
M
AUX1
AUX2
ABCD
FE
TE
SE
PEAK
BOTM
M901
(SPINDLE)
TH501
SWDT
SCLK
XLAT
ABCD
PEAK HOLD
Q301
EMPHASIS
PSB 16
LOADING
END
ON: When completion of
the disc loading.
(LIMIT)
ON: When the optical pick-up is
inner position.
MDX-C8500R/C8500X
5-2.
BLOCK DIAGRAM – TUNER Section –
B/U +5V
TUNER VCC
TUNER +5V
B/U 5V
2 FM-ANT
16
MPX
MPX 10
D
(Page 21)
E
(Page 21)
F
(Page 21)
H
(Page 21)
FMAGC
SMETER
RDSDET
SDA
SCL
AM IF
MUTING
Q202
EEPROM SDA
EEPROM SCL
AM-ANT
17 18
4
14
9
12 13
19
AMDET
AM
8
MUTING
Q205
D202
MUTING
CONTROL SWITCH
Q206, 207
DATA
CLOCK
AM IF
DATA, CLOCK
DATA
CLOCK
(MDX-C8500R)
RDS DECODER
IC201
SC
57 kHz
OUT
18
16
BAND-PASS
MPX
FILTER
MPTH
SIGNAL
QUALITY
DECODER
CLOCKED
COMPARATOR
RDS/RDBS
DEMODULATOR
& DECODER
5
4
INTERFACE
REGISTER
IIC BUS
SLAVE
TRANSCEIVER
SDA
9
SCL
10
BUFFER
Q209
2
5
4
DAVN
OSCILLATOR
& CLOCK
OSCO
MULTI
PATH
DETECTOR
CIN
OSCI
20
LVIN
19
BAND-PASS
FILTER
IC202
8
Q208
NOISE DET
DISCHARGE
SWITCH
X101
4.332MHz
(MDX-C8500X)
QUALITY
VSM
MTP
75
56
50
32
TUMUTE
52
QUALITY
53
NS-MASK
51
DAVN
10 11
FMAGC
SMETER
T.ROM-SDA
T.ROM-SCL
1
5
VCC
11
CN102
(FM/AM ANTENNA)
TUNER 5V
FM/AM TUNER UNIT
TUX201
MASTER CONTROLLER
IC502 (1/4)
I
(Page 21)
G
(Page 21)
• SIGNAL PATH
: FM
: AM (MW/LW)
05
20
20
MDX-C8500R/C8500X
5-3.
BLOCK DIAGRAM – MAIN Section –
(MDX-C8500R)
A
DADT,
BCK,
LRCK,
512FS
DADT
9
LRCK
2
BCK
5
DIGITAL SIGNAL PROCESSOR,
ANALOG +8V
DIGITAL FILTER,
D/A CONVERTER
FL-OUT
AOUTL1 27
IC805
76 LRCK
RL-OUT
AOUTR1 29
75 BCK
FR-OUT
AOUTR3 54
RR-OUT
81 PLCLK
AOUTL3 52
8
10
3
1
6
4
CENTER VOLTAGE
GENERATOR
(FOR BIAS)
IC809 (2/2)
71 SI1
512FS
(Page 19)
IC806
AOUTR2 43
R-CH
CN302 (2/2)
LOW-PASS
FILTER
IC807
34
33
ACINLF
OUTLF
ACINLR
R-CH
R-CH
LOW-PASS
FILTER
IC809 (1/2)
SUB-OUT
35
MONO FADER
MIXER
OUTLR
30
29
MONO OUTSWR
25
FADER
SUBWOOFER
+PHASE CONTROL
LINE
DRIVER
IC303
L
(MDX-C8500X)
R-CH
R
MUTING
Q357
SWINR
L
X801
16.9344MHz
46 RIN
XTLO38 40
82 XECKSTP
D352
61 63 59 62 60 57
BATT B+
TRDT
RVDT
SCK
XLAT
REDY
DSPRST
DSPPLL
XMST
LEVEL SHIFT
IC803 (2/2)
R-CH
TRDT
RVDT
SCK
XLAT
REDY
XRST
11
L
R
R-CH
1
E
AM
11
SEL
LOUDNESS/
VOLUME
AM
(Page 20)
SOFT
MUTE
MUTE
ACOUTL
TONE
CONTROL
38
25
26
27
35
78
36
(L)
MUTING
Q360
(MDX-C8500X)
(R)
R-CH
DSPSI
DSPSO
MUTING
CONTROL SWTICH
Q354, 355
ATT 5
DSPCKO
DSPLAT
CN301
MUTING
Q361
SUB OUT
D354
DSPREADY
DSPRST
DSPDATA
DSPCKO
TO
OUTPUT
SELECTOR
LOUDNESS
MUTING
Q359
(MDX-C8500R)
BATTERY OFF
MUTE DRIVER
Q352
29 DSPMST
28 DSPPLL
TRDT
RVDT
SCK
XLAT
REDY
DSPRST
INPUT SELECT, FM MPX
IC301 (1/2)
INPUT
MULTIPLEXER
BUS
AUDIO IN
R
LINE
DRIVER
IC304
XMST
DSPPLL
CN302 (1/2)
AUDIO
OUT REAR
MUTING
Q358
77 XMST
12
AUDIO
OUT FRONT
MUTING
Q356
XTLI38 41
35 LIN
R-CH
ELECTRICAL VOLUME
IC301 (2/2)
OUTPUT
SELECTOR
LEVEL SHIFT
IC803 (1/2)
SM
31 VOLATT
18
CN101 (1/2)
(POWER CONNECTOR)
POWER AMP
IC351
1
OUT2+ 5
F
AM IF
12
AMIF
MASTER CONTROLLER
IC502 (2/4)
AM/FM
NOISE
BLANKER
(Page 20)
FL+
12 IN2
9
OUT2–
FL–
3
4
OUT4+ 21
D
MPX
13
MPX
DEMODULATOR
+STEREO ADJUST
+STEREO BLEND
PILOT
CANCELATION
L.P.F.
(Page 20)
PLL
FR+
14 IN4
L.P.F.
S&H
HIGH-CUT
12
OUT4– 23
R-CH
FR–
2
OUT1+ 9
PILOT
DET
RL+
11 IN1
10
OUT1– 7
RL–
D/A
CONVERTER
DIGITAL
CONTROL
QUAL
3
OUT3+ 17
MULTIPATH
DETECTOR
11
DATA
16
15
14
4
15
DATA
(Page 20)
I
22 MUTE
STBY
LEVEL
MPIN
MPOUT
SCL
QUALITY
18
MUTING
CONTROL SWITCH
Q353
CLOCK
SDA
H
DATA, CLOCK
21
RR–
OUT3– 19
IIC BUS
20
RR+
15 IN3
CLOCK
TESTIN 84
70 I2C SDA
TELATT 96
13
LEVEL SHIFT
Q111
D353
71 I2C SCL
MD-ATT
QUALITY
(Page 20)
TEST
TEL-ATT
C
(Page 19)
AMPON 55
(MDX-C8500X)
AMPON
K
(Page 23)
G
SMETER
• SIGNAL PATH
(Page 20)
: MD PLAY
J
: FM
DSPDATA, DSPCKO
: AM (MW/LW)
(Page 22)
B
: BUS AUDIO IN
EMPHASIS
97 EMPH
(Page 19)
05
21
21
MDX-C8500R/C8500X
5-4.
BLOCK DIAGRAM – DISPLAY/KEY CONTROL Section –
D611
LSW751,901–917,
S901 – 904
ROTARY
ENCODER
RE901
J651
REMOTE IN
RE901
VOLUME/BASS/
TREBLE/BALANCE/
FADER CONTROL
D701
KEYIN0
KEYIN1
REIN0
KEYACK
80
117
15
BZ101
(BUZZER)
LED751
(MD DISC SLOT),
LSW751
Z
B+ SWITCH
Q751, 752
118
DOORIND
79
BEEP
116 115
NOSE-SW
47
BUZZER
DRIVE
Q351
S102
(NOSE DETECT)
B/U +5V
AD-ON
46
REIN1
48 72
RCIN0
RCIN1
KEY ACTIVE
SWITCH
Q701, 702
BOOT
RX
TX
X1
X0
X1A
X0A
106
12
13
93
92
73
74
CN701
MAIN BODY SIDE
CN901
FRONT PANEL SIDE
14
1
X104
3.68MHz
DSPDATA,DSPCKO
X105
18.432MHz
86
85
62
EXTAL
XTAL
RX
LIQUID CRYSTAL DISPLAY
DRIVE CONTROLLER
IC701 (1/2)
LCD B+
MDX-C8500R : LSW901 – 908,
LSW910 – 917
MDX-C8500X : LSW901 – 908,
LSW912 – 917
LED910 – 915
(LCD BACK LIGHT)
LCD-CE1
57
TX/LCD-DATA
LCD-SCK
61 63 33
BOOT
TRDT
SCK
J
4
SP-SI
SP-SCK
SP-LAT
(Page 21)
SA LAT
MASTER CONTROLLER
IC502 (3/4)
60 64 66
LED
DRIVE
Q902
(MDX-C8500X)
LED
DRIVE
Q901
LED DRIVE
Q903
(MDX-C8500X)
C953, R957
(MDX-C8500R)
SEG1 – SEG74
COM1 – COM8
1 – 74
83 – 76
LIQUID CRYSTAL DISPLAY
LCD901
22
22
86
(MDX-C8500R)
LIQUID CRYSTAL DISPLAY DRIVER
IC901
05
84
DIMMER
OSC
85
AMBER
96
GREEN
100 99 98
LCD-DATA
LCD-CLK
LCD-CE
OSC
X103
32.768kHz
LCD B+
MDX-C8500R/C8500X
5-5.
BLOCK DIAGRAM – BUS CONTROL/POWER SUPPLY Section –
DSP +5V
MASTER CONTROLLER
IC502 (4/4)
REMOTE CONTROL
RECEIVER
IC951
D605
3
+3.3V REGULATOR
IC801, Q801
24 SIRCS
RAM RESET
IC504
B/U +5V
BATT B+
POWER AMP
(IC351) B+
CN101 (2/2)
(POWER CONNECTOR)
F1
SWITCHING
REGULATOR
Q103, 105 106
16
+B
85 RAMBU
4
RESET SIGNAL
GENERATOR
IC503
B/U +5V
ANALOG +3.3V
DSP CIRCUIT B+
SIRCS
BUFFER
Q605
SIRCS
DIGITAL +3.3V
+3.3V REGULATOR
IC802
IN
ERROR
AMP
PWN
COMPARATOR
90 RESET
86 HSTX
S101
RESET
7
OSC SWITCH
Q101
RT
OSC
OUTPUT
CIRCUIT
POWER CONTROL
IC302
OUT
1
B+ SWITCH
Q102, 104
VCC 2
F CH 98
D502
D614
SONY BUS INTERFACE
IC601
FSW IN 65
DSPON 110
2
RST
2
RESET
RESET
SWITCH
RST
6 SYSRST
13
D104
ACCESSORY
CHECK
Q112
ACCIN 81
5
DATA
DATA IN
6
DATA
DATA OUT
4
4
CLK
BUS ON SWITCH
Q603
6
7
BATT
18 UNISO
8
17 UNISI
BATT
3
ILLIN 95
77 BU-IN
ACC
ILLUMINATION
LINE DETECT
Q113
D108
ANTENNA REMOTE
SWITCH
Q364, 366
TH103
AMP REMOTE
SWITCH
Q363, 365
TH102
14
ILL
ANALOG +8V
TUNER +5V
TUNER CIRCUIT/
RDS DECODER
(IC201) B+
4 BUS-ON
BATTERY BU IN
10
SWITCH
7
TUNER VCC
(TUNER CIRCUIT B+)
9 UNICKO
11
BUS ON
BUS
OUT
BUS ON ON IN
12
SWITCH
1
BUS ON
CLK IN
CLK
9
D109
+5V
REGULATOR
Q201
B+ SWITCH
Q203, 204
+8V
REGULATOR
Q107 – 109
6
ANT-R
PWON 83
TUNON 113
CN601
BUS CONTROL IN
TH101
D607
CDMD ON 116
(FOR SONY BUS)
D603
BATT B+
FLASH ON 82
BATTERY
DETECT
Q604
LCD B+
LCD DRIVER
(IC901) B+
LIQUID CRYSTAL DISPLAY
DRIVE CONTROLLER
IC701 (2/2)
LEVEL SHIFT
Q602
38 BUS-ON
ILL-ON 52
D703
LO +12V
LOADING MOTOR
DRIVER (IC306) B+
101 UNICKI
98 UNISI
97 UNISO
B+ SWITCH
Q402, 403
VCC
50 LINK OFF
MD MECHANISM CONTROLLER
IC501 (2/2)
+3.3V
60 BU-IN
DRIVER +5V
MOTOR/COIL
DRIVER
(IC303) B+
61 BUS-ON
30 RESET
LEVEL SHIFT
Q601
K
(Page 21)
81 RESET
48 UNICKIO
49 UNISI
50 UNISO
5
AMP-R
AMPON
LED901 – 904 (ILLUMINATION)
LSW909 DSO
82 NMI (H)
49 BU-IN
LEVEL SHIFT
IC702
REGULATOR
Q703 – 705
MD-ON 65
MDMON 10
05
23
23
+3.3V
REGULATOR
IC401, Q401
+12V
REGULATOR
Q401, 404, 405
B+ SWITCH
Q406, 407
B/U +5V
+5V
REGULATOR
Q110
5-6.
• Circuit Boards Location
NOTES FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS
Note on Printed Wiring Board:
• X : parts extracted from the component side.
• Y : parts extracted from the conductor side.
z
: Through hole.
•
f
•
: internal component.
• b : Pattern from the side which enables seeing.
(The other layers' patterns are not indicated.)
Caution:
Pattern face side:
(Conductor Side)
Parts face side:
(Component Side)
Parts on the pattern face side seen from
the pattern face are indicated.
Parts on the parts face side seen from
the parts face are indicated.
Note on Schematic Diagram:
• All capacitors are in µF unless otherwise noted. pF: µµF
50 WV or less are not indicated except for electrolytics
and tantalums.
• All resistors are in Ω and 1/4 W or less unless otherwise
specified.
f
•
: internal component.
• C : panel designation.
SENSOR board
DSO board
SERVO board
Note: The components identified by mark 0 or dotted line
with mark 0 are critical for safety.
Replace only with part number specified.
SUB board
• U : B+ Line.
• Power voltage is dc 14.4V and fed with regulated dc power
supply from ACC and BATT cords.
• Voltages are taken with a VOM (Input impedance 10 MΩ).
Voltage variations may be noted due to normal production tolerances.
• Waveforms are taken with a oscilloscope.
Voltage variations may be noted due to normal production tolerances.
• Circled numbers refer to waveforms.
• Signal path.
F : FM
f : AM (MW/LW)
L : BUS AUDIO IN
E : MD PLAY
• Please refer to servicing notes (page 3) for system of
TYPE A, B and C.
KEY board
MAIN board
24
24
• Waveforms
– SERVO Board –
– MAIN Board –
1 IC301 qh (OSCI) (MD Play Mode)
6 IC301 uf (TE), IC302 wh (TE)
(MD Play Mode)
4.6 Vp-p
7 IC302 1, 2, r;, rh (I, J, AGCI, RFO)
(MD Play Mode)
3.8 Vp-p
354 ns
354 ns
8 Q103, 106 (Emitter)
6 Vp-p
30.5 µs
44.3 ns
9 IC304 3 (MD Play Mode)
4 IC301 tg (RFI), IC302 ek (RF)
(MD Play Mode)
3.4 µs
3.4 µs
3 IC502 ud (X1A)
3 IC805 ra (XTLI38)
2.7 Vp-p
6.6 Vp-p
3.4 µs
4 IC502 od (X1)
4 Vp-p
7 Vp-p
4.6 Vp-p
4.1 Vp-p
2 IC803 6 (MD Play Mode)
7 Q103, 106 (Base)
3.7 Vp-p
101 ns
22.7 µs
3.4 µs
231 ns
2 IC502 yg (F OSC)
qs IC501 ea (EXTAL)
8 IC304 1, 2 (MD Play Mode)
4.1 Vp-p
3.9 Vp-p
12.6Vp-p
Apporx.
0.6 Vp-p
22.7 µs
3 IC301 wh (XBCK) (MD Play Mode)
1 IC803 3 (MD Play Mode)
5.8 Vp-p
4.4 Vp-p
44.3 ns
44.3 ns
2 IC301 wg (LRCK) (MD Play Mode)
6 IC302 1 (OUT)
1 IC201 4 (OSCO)
qa IC304 7 (MD Play Mode)
Approx.
2 Vp-p
– DSO Board –
59.1 ns
9 Q105 (Base)
– KEY Board –
1 IC901 oh (OSC)
2.6 Vp-p
6.1 Vp-p
Apporx.
1.5 Vp-p
3.6 Vp-p
3.1 Vp-p
5 IC301 yg (FE), IC302 ef (FE)
(MD Play Mode)
3.4 µs
272 ns
44.3 ns
0 Q105 (Collector)
5 IC701 ih (EXTAL)
0 IC304 5, 6 (MD Play Mode)
22.7 µs
3.8 Vp-p
Approx.
0.5 Vp-p
15.2 Vp-p
3 Vp-p
54.2 ns
44.3 ns
25
25
3.4 µs
MDX-C8500R/C8500X
5-7. PRINTED WIRING BOARDS – SERVO Board (Component Side)/SENSOR Board –
C
• Semiconductor
Location
A-12
D-11
IC301
IC302
IC303
IC304
IC305
IC306
IC401
IC501
IC502
IC503
D-7
I-9
F-7
C-8
B-13
E-6
A-12
G-13
D-10
E-10
Q301
Q302
Q401
E-5
I-8
B-11
7
8
9
10
11
12
13
14
SERVO BOARD
(LOADING END)
5
(COMPONENT SIDE)
4
K
R405
D401
D501
6
M903
(LOADING)
IC401
R404
Location
5
RED
E
B
8
1
C
M
C402
Ref. No.
4
C306
BLK
C403
Q401
C11
A
D401
C406
C352
1
8
R319
IC305
(CHASSIS)
29
30
C305
4
R318
5
R311
11
R320
R313
C308
50
26
CN103
51
R325
1
25
8
8
5
7
R324
IC304
C310
IC301
R328
(CHASSIS)
11
R354
B
3
FB302
A
2
R314
1
• See page 24 for Circuit Boards Location.
1
CN101
IC502
4
R327
SENSOR FLEXIBLE
BOARD
C311
RED
D501
M
R306
76
BLK
M
A
100
8
R305
M902
(SPINDLE)
E C B
R329
1
K
R307
1
R331
M902
(SLED)
75
1
A
IC503
R303
R330
1-676-656-
11
IC306
1
(11)
3
1
R302
4
R353
R352
C343
C342
R301
14
MAIN BOARD
CN301
2
R517
C315
R351
BLK
C348
5
RED
11
7
R304
Q301
E
1-654-693-
R538
SENSOR BOARD
(COMPONENT SIDE)
C314
D
14
R308
1
(Page 31)
C339
F
32
17
80
R536
R518
65
C349
1
(LIMIT)
R537
R522
L303
R523
L304
R524
(CONDUCTOR SIDE)
R525
SENSOR BOARD
64
IC303
R501
1
16
R502
C336
R503
G
L306
IC501
R531
C516
L305
R539
+ C318
OPTICAL
PICK-UP
BLOCK
(KMS-241C)
48
36
C327
1-676-656-
(11)
26
26
R345
R344
R343
R527
R507
R528
R506
+
C346
R340
R339
R341
R350
R357
R336
R349
Q302
B C E
C322
R348
C321
R346
R347
24
C324
C320
R337
I
13
C347
C325
25
12
L302
R532
IC302
05
40
R511
20
11
25
X501
C326
LOADING START
EJECT END
41
37
1
CN102
24
C501
C329
C330
+ C319
(CHASSIS)
C328
R356
1
R505
R355
C331
H
R516
R504
R535
(CHASSIS)
R526
R529
11
R342
R338
1-675-655-
(11)
MDX-C8500R/C8500X
5-8. PRINTED WIRING BOARD – SERVO Board (Conductor Side) –
1
A
2
3
4
• See page 24 for Circuit Boards Location.
5
6
7
8
9
• Semiconductor
Location
SERVO BOARD
(CONDUCTOR SIDE)
Ref. No.
C510
R403
Q402
B
E
B C E
C
+ C361
C362
Q403
13
9
5
1
IC307
C307
C359
R358
22
26
C309
C353
18
C302
14
C345
L301
+ C344
C
C317
R547
C358
C301
C356
D
C511
C357
R335
R333
R332
+
R334
L501
C506
E
C316
C512
C505
RB302
RB301
+ C351
R534
R533
C515
C350
C504
F
C514
R540
R520
R542
R521
C513
G
C333
R519
H
R510
TH501
C503
R512
C-8
Q402
Q403
B-4
B-4
R402
R401
B
Location
IC307
RB503
I
11
05
1-675-655-
27
27
(11)
MDX-C8500R/C8500X
5-9.
SCHEMATIC DIAGRAM – SERVO Board (1/2)/SENSOR Board –
• Voltages and waveforms are dc with respect to ground
under no-signal conditions.
no mark : MD PLAY
: Impossible to measure
∗
• See page 25 for Waveforms.
• See page 42 for IC Block Diagrams.
The components identified by mark 0 or dotted
line with mark 0 are critical for safety.
Replace only with part number specified.
28
28
MDX-C8500R/C8500X
5-10.
SCHEMATIC DIAGRAM – SERVO Board (2/2) – • See page 25 for Waveforms.
(Page
34)
• Voltages and waveforms are dc with respect to ground
under no-signal conditions.
no mark : MD PLAY
: Impossible to measure
∗
29
29
MDX-C8500R/C8500X
5-11.
PRINTED WIRING BOARD – MAIN Board (Component Side) –
• See page 24 for Circuit Boards Location.
• Semiconductor Location
Ref. No.
Location
Ref. No.
Location
D101
D102
D104
D105
D106
D107
D108
D109
D201
D202
D203
D204
D205
D301
D302
D352
D353
D354
D501
D601
D602
D603
D607
D608
D609
D610
D614
D701
D702
D703
D751
D752
D753
D754
D755
D756
D757
D758
D759
D760
D761
D762
I-4
I-4
H-5
F-8
B-2
B-1
K-3
J-3
G-12
D-13
F-11
F-11
F-12
C-6
D-7
C-8
C-7
C-8
H-7
G-7
H-7
F-8
F-7
G-7
F-7
G-7
G-8
J-12
I-11
I-13
K-12
J-12
K-13
J-11
K-11
J-12
J-12
K-13
K-13
J-13
K-11
J-13
IC503
IC504
IC601
IC701
IC702
J-5
K-5
G-7
J-10
H-11
IC201
IC202
IC301
IC302
IC303
IC304
IC305
IC502
H-12
F-12
G-10
I-3
D-9
D-11
D-10
I-7
Q101
Q102
Q103
Q106
Q108
Q109
Q111
Q112
Q113
Q201
Q202
Q203
Q204
Q205
Q206
Q207
Q208
Q209
Q351
Q352
Q353
Q354
Q355
Q356
Q357
Q358
Q359
Q360
Q361
Q363
Q364
Q365
Q366
Q404
Q405
Q407
Q601
Q602
Q603
Q604
Q605
Q701
Q702
Q703
Q705
I-4
H-4
H-4
H-4
E-8
E-8
K-7
J-4
K-4
G-13
E-13
E-12
E-11
E-13
D-13
D-13
F-11
F-13
K-3
C-8
C-7
C-6
C-7
B-10
B-10
B-11
B-11
C-12
D-12
D-5
D-5
D-4
D-4
E-5
F-5
F-5
G-7
H-7
F-7
F-8
D-2
J-12
J-13
I-13
I-13
30
30
MDX-C8500R/C8500X
5-12.
PRINTED WIRING BOARD – MAIN Board (Conductor Side) –
• See page 24 for Circuit Boards Location.
6
5
8
3
• Semiconductor
Location
4
7
2
1
Ref. No.
(FRONT VIEW)
(C8500R)
GRN
TO
CN101
WHT
GRY
VIO
WHT
GRN
VIO
GRY
RL+
RL–
FL+
FL–
FR+
FR–
RR+
RR–
1
9
2
10
3
11
4
12
5
13
6
14
7
15
GRN/BLK
WHT/BLK
GRY/BLK
VIO/BLK
WHT/BLK
GRN/BLK
VIO/BLK
GRY/BLK
LIGHT BLU
BLU/WHT
BLU
RED
BLK
RED
8
16
ACC
GND
ILL
BLU
ANT REM
NC
BATT
NC
NC
ATT
AMP REM
ORG/WHT
YEL
BLK
ORG/WHT
YEL
(C8500X)
1
9
2
10
3
11
4
12
WHT/BLK
WHT
GRN/BLK
GRN
VIO/BLK
VIO
GRY/BLK
GRY
5
13
LIGHT BLU
BLU/WHT
6
14
ORG/WHT
BLU
7
16
YEL
BLK
(Page
36)
(Page 26)
(Page 38)
31
31
FRONT LCH (+)
REAR LCH (–)
REAR LCH (+)
REAR RCH (–)
REAR RCH (+)
FRONT RCH (–)
FRONT RCH (+)
ATT
AMP REM
ILL IN
ANT REM
15
RED
8
FRONT LCH (–)
ACC
BATT
GND
Location
D103
D355
D356
D357
D358
D359
D360
D361
D362
D363
D502
D604
D605
D606
D611
D612
D613
G-3
C-7
C-7
C-6
C-6
B-8
B-7
B-8
B-8
C-2
J-8
C-2
B-2
C-2
D-1
D-2
D-2
IC351
B-7
Q104
Q105
Q107
Q110
Q401
Q406
Q704
F-4
G-3
E-8
B-1
E-4
F-5
J-13
MDX-C8500R/C8500X
5-13.
SCHEMATIC DIAGRAM – MAIN Board (1/4) –
• See page 25 for Waveforms.
• See page 42 for IC Block Diagrams.
(Page 37)
(Page
33)
(Page 34)
• Voltages and waveforms are dc with respect to ground
under no-signal (detuned) conditions.
no mark : FM
(
) : AM (MW)
[
] : LW
32
32
MDX-C8500R/C8500X
5-14.
SCHEMATIC DIAGRAM – MAIN Board (2/4) –
• See page 42 for IC Block Diagrams.
(Page
32)
(Page 34)
• Voltages are dc with respect to ground under no-signal
(detuned) conditions.
no mark : FM
(Page 35)
33
33
MDX-C8500R/C8500X
5-15.
SCHEMATIC DIAGRAM – MAIN Board (3/4) –
• See page 25 for Waveforms.
• See page 42 for IC Block Diagrams.
(Page 32)
(Page
33)
(Page
29)
(Page
35)
• Voltages and waveforms are dc with respect to ground
under no-signal (detuned) conditions.
no mark : FM
(
) : AM (MW)
[
] : LW
〈〈
〉〉 : MD PLAY
34
34
MDX-C8500R/C8500X
5-16.
SCHEMATIC DIAGRAM – MAIN Board (4/4) –
• See page 25 for Waveforms.
(Page 33)
(Page
34)
(Page
39)
• Voltages and waveforms are dc with respect to ground
under no-signal (detuned) conditions.
no mark : FM
35
35
MDX-C8500R/C8500X
5-17.
PRINTED WIRING BOARD – DSO Board –
• See page 24 for Circuit Boards Location.
(Page 31)
• Semiconductor
Location
(Conductor Side)
• Semiconductor
Location
(Component Side)
Ref. No.
Ref. No.
Location
Location
D804
B-5
D802
C-1
IC801
IC803
IC806
IC809
A-2
B-2
B-1
B-5
IC802
IC805
IC807
IC808
B-1
B-3
A-5
B-5
Q801
A-3
36
36
MDX-C8500R/C8500X
5-18.
SCHEMATIC DIAGRAM – DSO Board –
• See page 25 for Waveforms.
• See page 42 for IC Block Diagrams.
(Page
32)
• Voltages and waveforms are dc with respect to ground
under no-signal conditions.
no mark : MD PLAY
: Impossible to measure
∗
37
37
MDX-C8500R/C8500X
5-19.
PRINTED WIRING BOARD – SUB Board –
• See page 24 for Circuit Boards Location.
(Page 31)
(Page 40)
38
38
MDX-C8500R/C8500X
5-20.
SCHEMATIC DIAGRAM – SUB Board –
(Page 41)
(Page 35)
• Voltages are dc with respect to ground under no-signal
(detuned) conditions.
no mark : FM
39
39
MDX-C8500R/C8500X
5-21.
PRINTED WIRING BOARD – KEY Board –
• See page 24 for Circuit Boards Location.
• Semiconductor
Location
(Component Side)
Ref. No.
Location
IC951
C-5
LED901
LED902
LED903
LED904
LED910
LED911
LED912
LED913
LED914
LED915
C-2
A-2
A-3
C-3
B-12
B-12
A-12
A-5
B-5
B-5
• Semiconductor
Location
(Conductor Side)
Ref. No.
Location
D901
D902
D903
D904
D951
D952
D954
B-13
C-11
C-11
C-11
C-5
B-10
B-10
IC901
B-8
Q901
Q902
Q903
A-3
A-3
A-5
(Page 38)
40
40
MDX-C8500R/C8500X
5-22.
SCHEMATIC DIAGRAM – KEY Board –
• See page 25 for Waveforms.
(Page
39)
• Voltages and waveforms are dc with respect to ground
under no-signal (detuned) conditions.
no mark : FM
41
41
MNT2 3
AUTO
SEQUENCER
EACH
BLOCK
ADDC
COMPP
COMPO
AGCI
RF AGC
RF
PEAK
OPN
43 42
41
40
39
38
37
RF AGC
+
–
RFA2
I
74 TE
73 SE
J
1
–1
–
–2
–
2
RFA3
HLPT
–1
70 ADRT
SCLK 6
68 ADIO
EACH
BLOCK
CVB
VC
3
AUX
SW
P-P
–2
OFST
69 AVDD
EQ
PEAK3T
3T
72 AVSS
SWDT 5
EQ
USRC
DET
75 AUX2
ADIP
DECODER
SRDT 8
44
USROP
BPF3T
71 ADRB
CPU I/F
OPO
RFO
DCHG
APC
ADFG
F0CNT
XLRF
CKRF
DTRF
APCREF
LDDR
TRDR
TFDR
DVDD
FFDR
FRDR
FS4
PWM
GENERATOR
MNT3 4
XLAT 7
45
92 91 90 89 88 87 86 85 84 83 82 81 80 79 78 77 76
SPINDLE
SERVO
MONITOR
CONTROL
46
3T
PTGR
WBL
TEMP
PEAK
–
1
–
–2
–
+
MNT1 2
47
–
+
RFA1
MNT0 1
48
+
–
94 93
SRDR
SFDR
SPRD
SPFD
FGIN
TEST1
TEST2
TEST3
DVSS
100 99 98 97 96 95
MORFI
CXA2523AR
CDX2652AR
EFMO
IC301
IC302
MORFO
• IC Block Diagrams
– SERVO Board –
–2
BOTTOM
PBSW
GRVA
36 BOTM
PBH
–1
GRV
WBL
35 ABCD
67 VC
SERVO
DSP
SENS 9
A/D
CONVERTER
66 AUX1
A
65 FE
ANALOG
MUX
IVR
64 ABCD
XRST 10
+
–
4
34 FE
–
–
–
–
AA
33 AUX
BPFC
ABCDA
63 BOTM
DQSY 12
32 ADFG
62 PEAK
SUBCODE
PROCESSOR
B
PLL
XINT 14
IVR
31 ADAGC
BB
+
+
–
–
60 FILO
59 FILI
EFM/ACIRC
ENCODER/
DECODER
SHOCK RESISTANT
MEMORY CONTROLLER
+
–
5
61 CLTV
RECP 13
58 PCO
C
TX 15
+
–
6
IVR
57 PDO
CC
DET
BPF22
56 AVSS
–
–
+
+
OSCI 16
OSCO 17
XTSL 18
CLOCK
GENERATOR
EACH
BLOCK
D
DIGITAL
AUDIO
I/F
NC 19
DVSS 20
+
–
7
55 RFI
COMP
SAMPLING
RATE
CONVERTER
30 ADIN
FEA
IVR
ADIP
AGC
WBL
ATA
DD
54 BIAS
WBL
–1
53 AVDD
DIN 21
52 ASYI
DOUT 22
E
+
–
8
51 ASYO
IVR
+
–
EE
PTGR
–
+
–
+
EE'
–2
–2
ESW
ATRAC
ENCODER/DECODER
F
+
–
9
IVR
LRCK 25
FF
IV
3T
AUXSW
+
50
25 WBLADJ
VI CONV
BGR
COMMAND
–
MVCI
+ –
VREF
SCRI - PARA
DECODE
APC 11
42
42
13
14
15
16
17
18
19
20
21
22 23
24
TEMPI
TEMPR
SWDT
SCLK
XLAT
XSTBY
F0CNT
VREF
EQADJ
VCC
APCREF 12
GND
D3
D2
D0
D1
XWE
XRAS
A09
XCAS
XOE
DVSS
A11
A08
A07
A06
A05
A04
A10
A01
A00
A02
A03
DVDD
FS256
XBCK
29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49
26 TE
TEA
EQ
PD 10
26 27 28
TG
WBL
FF'
FBAL
GSW
ADDRESS/DATA BUS A00 - A11, D0 - D3
+
–
28 SE
SEA
–1
TESW
EBAL
DADT 24
TG
27 CSLED
EFB
ADDT 23
29 ADFM
3TADJ
SQSY 11
CAPA+
IN2R
IN2F
VM2
OUT2F
PGND2
OUT2R
VM12
OUT1R
PGND1
OUT1F
VM1
IN1F
IN1R
VDD
BH6511FS
CAPA–
IC303
32
31
30
29
28
27
26
25
24
23
22
21
20
19
18
17
INTERFACE
PREDRIVE
PREDRIVE
PREDRIVE
7
8
9
IN4F
VM4
OUT4F
PGND4
OUT4R
VM34
10
11
12
13
14
15
16
PSB
6
IN3R
5
PSB
IN3F
4
INTERFACE
VM3
3
AMP
OUT3F
2
IN4R
AMP
VDD
PGND3
AMP
AMP
VG
GND
IC305
AMP
PREDRIVE
INTERFACE
1
AMP
OUT3R
CHARGE
PUMP.
OSC
AMP
AMP
INTERFACE
BA6287F
OUT1 1
8 GND
VM 2
7 OUT2
DRIVER
DRIVER
TSD
VCC 3
6 VREF
CONTROL LOGIC
POWER
SAVE
FIN 4
IC307
5 RIN
MN41V4400TT-08S
TIMING
GENERATOR
6
7
8
A0 9
A1 10
A2 11
A3 12
COLUMN
NC
NC
NC
25 DQ4
24 DQ3
ROW
1
2
3
4
5
ADDRESS BUFFERS
DQ1
DQ2
WE
RAS
A9
26 VSS
TIMING
GENERATOR
COLUMN
DECODERS
INTERNAL
ADDRESS
COUNTER
REFRESH
CONTROL
CLOCK
SENSE
AMPLIFIERS
ROW
DECODERS
WORD
DRIVERS
MEMORY
CELLS
I/O
SELECTOR
INPUT
BUFFERS
WRITE
CLOCK
GENERATOR
OUTPUT
BUFFERS
23 CAS
22 OE
21 NC
20 NC
19 NC
18
17
16
15
14
A8
A7
A6
A5
A4
DATA BUS
VCC 13
43
– MAIN Board –
CIN
SCOUT
VREF
MPX
VSSA
VDDA
AFIN
MAD
PSWN
SAA6588T/V2-118
LVIN
IC201
20
19
18
17
16
15
14
13
12 11
PAUSE
DETECTOR
POWER SUPPLY
& RESET
MULTI
PATH
DETECTOR
57kHz
8th ORDER
BAND-PASS FILTER
CLOCKED
COMPARATOR
SIGNAL QUALITY
DECODER
4
5
CLOCK
RDS/RDBS
DEMODULATOR
4
CLOCK
RDS/RDBS
DECODER
INTERFACE
REGISTER
DATA
DATA
3
4
5
6
7
8
9
10
OSCI
VSSD
VDDD
DAVN
SDA
SCL
VCC
OUT
IC303 – 305
FEED BACK
TL5001CD
INPUT
IC302
IIC BUS SLAVE
TRANSCEIVER
OSCO
MRO
MPTH
1 2
OSCILLATOR
& CLOCK
TCON
TEST
CONTROL
4
3
2
1
+
–
SWITCH
'ON'
AT
'H'
BUFFER
LIFT
AMP
BUFFER
REFERENCE
–
+
PWM
COMPARATOR
–
+
VCCL
SIGNAL
AMP
16 CL+
15 CL–
14 LGND
13 OUTL
INML 4
VCCR
S.C.P.
LATCH
INMR 5
12 OUTR
SIGNAL
AMP
5
6
7
8
SCP
DEAD-TIME
CONTROL
RT
GND
S.C.P.
COMPARATOR 2
11 RGND
REFERENCE
BUFFER
INR 7
VCCR 8
VCCR
LIFT
AMP
10 CR–
SVRR 6
44
VCCL
–
+
OSC
S.C.P.
COMPARATOR 1
INL 2
DEAD-TIME
COMPARATOR
REFERENCE
VOLTAGE
+
–
VCCL 1
SVRL 3
U.V.L.O
ERROR
AMP
NJM2160AM-TE2
BUFFER
9
CR+
OUTLF
OUTLR
OUTRF
OUTRR
OUTSWL
OUTSWR
OUTSSL
OUTSSR
TDA7402TR
ACINLR
ACINRF
ACINRR
IC301
33 32 31
30
29
28
27
26
25
24 23
MIXER
MONO- MONOFADER FADER
ACINLF 34
SWINR 35
SWINL 36
ACIN
ACOUTR 37
ACOUTL 38
MAIN
MONO- MONOFADER FADER
MONO- MONOFADER FADER
FRONT
OUTPUT
SELECTOR
SUBWOOFER
+PHASE
CONTROL
REAR
SW
SECOND
CREF 39
22 VDD
IIC-BUS
LP
VOICE
BANDPASS
HP
21 SCL
20 SDA
BASS
SUPPLY
TREBLE
DIGITAL CONTROL
HIGH-CUT
VOLUME
SOFTMUTE
COMPANDER
19 GND
18 SM
S&H
PULSE
FORMER
25kHz
LP
QUAL
17 QUAL
LOUDNESS
LOUDNESS
+
IN-GAIN
IN-GAIN
+AUTO ZERO
MUTE
MULTIPATH
DETECTOR
DEMODULATOR
+STEREO ADJUST
+STEREO BLAND
MUX 40
BEEP
D/A
CONVERTER
PILOT
CANCELATION
16 MPOUT
15 MPIN
14 LEVEL
PIL DET
MAIN SOURCE
SELECTOR
PLL
MAIN
INPUT
MULTIPLEXER
80kHz
LP
FM
13 MPX
MAIN
CH0
AUX
AM
1 2
3 4 5 6
7 8 9 10
11
FD2L+
FD2L–
FD2R+
FD2R–
AM
PHONO
FD1L+
FD1L–
FD1R+
FD1R–
MD2 43
MD2G 44
SECOND SOURCE
SELECTOR
SEL
SER
MD1 41
MD1G 42
MIXING
SELECTOR
AM/FM
NOISE BLANKER
12 AMIF
45
IC601
BA8270F-E2
BUS ON 1
BUS ON
SWITCH
RST 2
RESET
SWITCH
BATT 3
BATTERY
SWITCH
14 VCC
13
12
11
10
CLK 4
VREF 5
DATA 6
RST
BUS ON
CLK IN
BU IN
9 DATA IN
GND 7
8 DATA OUT
– DSO Board –
XRST
VSS2
AVS4
AOUTR3
AVD4
AOUTL3
AVD6
CXD2726Q-4
XPLLEN
AVSP
VDD3
XMST
LRCK
BCK
SIN
SI3
SI2
SI1
SOUT
SO3
SO2
SO1
VSS3
VDD2
XS24
RVDT
XLAT
TRDT
REDY
SCK
BFOT
IC805
80 79 78 77 76 75 74 73 72 71 70 69 68 67 66 65 64 63 62 61 60 59 58
57
56
55
54 53 52
51
SERIAL
DATA
I/F
SERIAL DATA
I/F
ADC2
PLCLK
XECKSTP
AVDP
VSS4
T. P
T. P
T. P
T. P
T. P
T. P
T. P
T. P
T. P
T. P
VDD4
AVSD
T. P
T. P
T. P
AVDD
81
82
83
84
85
86
87
88
89
90
91
92
93
94
95
96
97
98
99
100
ADC1
MICRO
COMPUTER
I/F
DSP
DIGITAL
FILTER
512kbit
DELAY
RAM
CLOCK
GENERATOR/
TIMING CIRCUIT
DAC6
–
+
DAC5
–
+
DAC4
–
+
DAC3
–
+
DAC2
–
+
DAC1
–
+
CLOCK
GENERATOR/
TIMING CIRCUIT
PLL
VSS1
T. P
T. P
T. P
T. P
T. P
T. P
T. P
T. P
T. P
T. P
T. P
T. P
T. P
T. P
TST0
TST1
TST2
TST3
TST4
TST5
JPE1
JPE2
JPE3
VDD1
AVS3
AOUTL1
AVD3
AOUTR1
AVD5
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30
46
50
49
48
47
46
45
44
43
42
41
40
39
38
37
36
35
34
33
32
31
AVS6
AVD2
AVS2
RREF
RIN
AVS8
AVD8
AOUTR2
AVSX
XTLI38
XTLO38
AVDX
AOUTL2
AVD7
AVS7
LIN
LREF
AVS1
AVD1
AVS5
5-23.
IC PIN FUNCTION DESCRIPTION
• SERVO BOARD IC301 CXD2652AR
(DIGITAL SIGNAL PROCESSOR, DIGITAL SERVO PROCESSOR, EFM/ACIRC ENCODER/DECODER,
SHOCK PROOF MEMORY CONTROLLER, ATRAC ENCODER/DECODER, 2M BIT D-RAM)
Pin No.
Pin Name
I/O
Description
1
MNT0
O
Focus OK signal output to the MD mechanism controller (IC501)
“H” is output when focus is on (“L”: NG)
2
MNT1
O
Track jump detection signal output to the MD mechanism controller (IC501)
3
MNT2
O
Busy monitor signal output to the MD mechanism controller (IC501)
4
MNT3
O
Spindle servo lock status monitor signal output to the MD mechanism controller (IC501)
5
SWDT
I
Writing serial data signal input from the MD mechanism controller (IC501)
6
SCLK
I
Serial data transfer clock signal input from the MD mechanism controller (IC501)
7
XLAT
I
Serial data latch pulse signal input from the MD mechanism controller (IC501)
8
SRDT
O (3)
Reading serial data signal output to the MD mechanism controller (IC501)
9
SENS
O (3)
Internal status (SENSE) output to the MD mechanism controller (IC501)
10
XRST
I
Reset signal input from the MD mechanism controller (IC501) “L”: reset
11
SQSY
O
Subcode Q sync (SCOR) output to the MD mechanism controller (IC501)
“L” is output every 13.3 msec Almost all, “H” is output
12
DQSY
O
Digital In U-bit CD format subcode Q sync (SCOR) output terminal
“L” is output every 13.3 msec Almost all, “H” is output Not used (open)
13
RECP
I
Laser power selection signal input terminal
“L”: playback mode, “H”: recording mode (fixed at “L” in this set)
14
XINT
O
Interrupt status output to the MD mechanism controller (IC501)
15
TX
I
Recording data output enable signal input terminal
Writing data transmission timing input (Also serves as the magnetic head on/off output)
Not used (fixed at “L”)
16
OSCI
I
System clock signal (512Fs=22.5792 MHz) input from the oscillator circuit
17
OSCO
O
System clock signal (512Fs=22.5792 MHz) output terminal Not used (open)
18
XTSL
I
Input terminal for the system clock frequency setting
“L”: 45.1584 MHz, “H”: 22.5792 MHz (fixed at “H” in this set)
19
RVDD
—
Power supply terminal (+3.3V) (digital system)
20
RVSS
—
Ground terminal (digital system)
21
DIN
I
Digital audio signal input terminal when recording mode Not used (fixed at “L”)
22
DOUT
O
Digital audio signal output terminal when playback mode Not used (open)
23
ADDT
I
Recording data input terminal Not used (fixed at “L”)
24
DADT
O
Playback data output to the CXD2726Q (IC805)
25
LRCK
O
L/R sampling clock signal (44.1 kHz) output to the CXD2726Q (IC805)
26
XBCK
O
Bit clock signal (2.8224 MHz) output to the CXD2726Q (IC805)
27
FS256
O
Clock signal (11.2896 MHz) output terminal Not used (open)
28
DVDD
—
Power supply terminal (+3.3V) (digital system)
29 to 32
A03 to A00
O
Address signal output to the D-RAM (IC307)
33
A10
O
Address signal output to the external D-RAM Not used (open)
34 to 38
A04 to A08
O
Address signal output to the D-RAM (IC307)
39
A11
O
Address signal output to the external D-RAM Not used (open)
40
DVSS
—
Ground terminal (digital system)
41
XOE
O
Output enable signal output to the D-RAM (IC307) “L” active
42
XCAS
O
Column address strobe signal output to the D-RAM (IC307) “L” active
43
A09
O
Address signal output to the D-RAM (IC307)
44
XRAS
O
Row address strobe signal output to the D-RAM (IC307) “L” active
45
XWE
O
Write enable signal output to the D-RAM (IC307) “L” active
47
Pin No.
Pin Name
I/O
46
D1
I/O
47
D0
I/O
48
D2
I/O
49
D3
I/O
50
MVCI
I
Digital in PLL oscillation input from the external VCO Not used (fixed at “L”)
51
ASYO
O
Playback EFM full-swing output terminal
52
ASYI
I (A)
53
AVDD
—
54
BIAS
I (A)
55
RFI
I (A)
56
AVSS
—
57
PDO
O (3)
Phase comparison output for clock playback analog PLL of the playback EFM Not used (open)
58
PCO
O (3)
Phase comparison output for master clock of the recording/playback EFM master PLL
59
FILI
I (A)
Filter input for master clock of the recording/playback master PLL
60
FILO
O (A) Filter output for master clock of the recording/playback master PLL
61
CLTV
I (A)
Internal VCO control voltage input of the recording/playback master PLL
62
PEAK
I (A)
Light amount signal (RF/ABCD) peak hold input from the CXA2523AR (IC302)
63
BOTM
I (A)
Light amount signal (RF/ABCD) bottom hold input from the CXA2523AR (IC302)
64
ABCD
I (A)
Light amount signal (ABCD) input from the CXA2523AR (IC302)
65
FE
I (A)
Focus error signal input from the CXA2523AR (IC302)
48
Description
Two-way data bus with the D-RAM (IC307)
Playback EFM asymmetry comparator voltage input terminal
Power supply terminal (+3.3V) (analog system)
Playback EFM asymmetry circuit constant current input terminal
Playback EFM RF signal input from the CXA2523AR (IC302)
Ground terminal (analog system)
66
AUX1
I (A)
Auxiliary signal (I3 signal/temperature signal) input terminal Not used (fixed at “H”)
67
VC
I (A)
Middle point voltage (+1.65V) input from the CXA2523AR (IC302)
68
ADIO
69
AVDD
—
70
ADRT
I (A)
A/D converter operational range upper limit voltage input terminal (fixed at “H” in this set)
71
ADRB
I (A)
A/D converter operational range lower limit voltage input terminal (fixed at “L” in this set)
72
AVSS
—
73
SE
I (A)
Sled error signal input from the CXA2523AR (IC302)
74
TE
I (A)
Tracking error signal input from the CXA2523AR (IC302)
75
AUX2
I (A)
Auxiliary signal input terminal Light amount signal input from the CXA2523AR (IC302)
76
DCHG
I (A)
Connected to the +3.3V power supply
77
APC
I (A)
Error signal input for the laser automatic power control Not used (fixed at “L”)
78
ADFG
I
ADIP duplex FM signal (22.05 kHz ± 1 kHz) input from the CXA2523AR (IC302)
79
F0CNT
O
Filter f0 control signal output terminal Not used (open)
O (A) Monitor output of the A/D converter input signal Not used (open)
Power supply terminal (+3.3V) (analog system)
Ground terminal (analog system)
80
XLRF
O
Serial data latch pulse signal output terminal Not used (open)
81
CKRF
O
Serial data transfer clock signal output terminal Not used (open)
82
DTRF
O
Writing serial data output terminal Not used (open)
83
APCREF
O
Control signal output to the reference voltage generator circuit for the laser automatic power
control
84
LDDR
O
PWM signal output for the laser automatic power control Not used (open)
85
TRDR
O
Tracking servo drive PWM signal (–) output to the BH6511FS (IC303)
86
TFDR
O
Tracking servo drive PWM signal (+) output to the BH6511FS (IC303)
87
DVDD
—
Power supply terminal (+3.3V) (digital system)
88
FFDR
O
Focus servo drive PWM signal (+) output to the BH6511FS (IC303)
Pin No.
Pin Name
I/O
Description
89
FRDR
O
Focus servo drive PWM signal (–) output to the BH6511FS (IC303)
90
FS4
O
Clock signal (176.4 kHz) output terminal (X’tal system)
91
SRDR
O
Sled servo drive PWM signal (–) output to the BH6511FS (IC303)
92
SFDR
O
Sled servo drive PWM signal (+) output to the BH6511FS (IC303)
93
SPRD
O
Spindle servo drive PWM signal (–) output to the BH6511FS (IC303)
94
SPFD
O
Spindle servo drive PWM signal (+) output to the BH6511FS (IC303)
95
FGIN
I
Not used (fixed at “L”)
96
TEST1
I
97
TEST2
I
98
TEST3
I
99
DVSS
—
Ground terminal (digital system)
100
EFMO
O
EFM signal output terminal when recording mode
Not used (open)
Input terminal for the test (fixed at “L”)
Not used (open)
* I (A) for analog input, O (3) for 3-state output, and O (A) for analog output in the column I/O.
49
• SERVO BOARD IC302 CXA2523AR (RF AMP, FOCUS/TRACKING ERROR AMP)
Pin No.
Pin Name
I/O
Description
1
I
I
I-V converted RF signal I input from the optical pick-up block detector
2
J
I
I-V converted RF signal J input from the optical pick-up block detector
3
VC
O
Middle point voltage (+1.65V) generation output terminal
4 to 9
A to F
I
Signal input from the optical pick-up detector
10
PD
I
Light amount monitor input from the optical pick-up block laser diode
11
APC
O
Laser amplifier output terminal to the automatic power control circuit
12
APCREF
I
Reference voltage input terminal for setting laser power
13
GND
—
50
Ground terminal
14
TEMPI
I
Connected to the temperature sensor Not used (open)
15
TEMPR
O
Output terminal for a temperature sensor reference voltage Not used (open)
16
SWDT
I
Writing serial data input from the MD mechanism controller (IC501)
17
SCLK
I
Serial data transfer clock signal input from the MD mechanism controller (IC501)
18
XLAT
I
Serial data latch pulse signal input from the MD mechanism controller (IC501)
19
XSTBY
I
Standby signal input terminal “L”: standby (fixed at “H” in this set)
20
F0CNT
I
Center frequency control voltage input terminal of internal circuit (BPF22, BPF3T, EQ) input
terminal
21
VREF
O
Reference voltage output terminal Not used (open)
22
EQADJ
I
Center frequency setting terminal for the internal circuit (EQ)
23
3TADJ
I
Center frequency setting terminal for the internal circuit (BPF3T)
24
VCC
—
25
WBLADJ
I
Center frequency setting terminal for the internal circuit (BPF22)
26
TE
O
Tracking error signal output to the CXD2652AR (IC301)
27
CSLED
I
Connected to the external capacitor for low-pass filter of the sled error signal
28
SE
O
Sled error signal output to the CXD2652AR (IC301)
29
ADFM
O
FM signal output of the ADIP
30
ADIN
I
Receives a ADIP FM signal in AC coupling
31
ADAGC
I
Connected to the external capacitor for ADIP AGC
32
ADFG
O
ADIP duplex signal (22.05 kHz ± 1 kHz) output to the CXD2652AR (IC301)
Power supply terminal (+3.3V)
33
AUX
O
Auxiliary signal (I3 signal/temperature signal) output terminal Not used (open)
34
FE
O
Focus error signal output to the CXD2652AR (IC301)
35
ABCD
O
Light amount signal (ABCD) output to the CXD2652AR (IC301)
36
BOTM
O
Light amount signal (RF/ABCD) bottom hold output to the CXD2652AR (IC301)
37
PEAK
O
Light amount signal (RF/ABCD) peak hold output to the CXD2652AR (IC301)
38
RF
O
Playback EFM RF signal output to the CXD2652AR (IC301)
39
RFAGC
I
Connected to the external capacitor for RF auto gain control circuit
40
AGCI
I
Receives a RF signal in AC coupling
41
COMPO
O
User comparator output terminal Not used (open)
42
COMPP
I
User comparator input terminal Not used (fixed at “L”)
43
ADDC
I
Connected to the external capacitor for cutting the low band of the ADIP amplifier
44
OPO
O
User operational amplifier output terminal Not used (open)
45
OPN
I
User operational amplifier inversion input terminal Not used (fixed at “L”)
46
RFO
O
RF signal output terminal
47
MORFI
I
Receives a MO RF signal in AC coupling
48
MORFO
O
MO RF signal output terminal
• SERVO BOARD IC501 CXP84340-217Q (MD MECHANISM CONTROLLER)
Pin No.
Pin Name
I/O
Description
1 to 5
TIN3 to TIN7
I/O
Input of the 4×8 matrix test keys (“L” is always output, except in test mode)
6
LOAD
O
Loading motor control signal output to the motor driver (IC305) “H” active *1
7
EJECT
O
Loading motor control signal output to the motor driver (IC305) “H” active *1
8, 9
NCO
O
Not used (open)
10
MDMON
O
Power supply on/off control signal output of the MD mechanism deck section main power supply
and loading motor drive (IC305) power supply “H”: power on
11
E-SW
I
Inputs the disc loading completion detect switch detection signal
“L”: When completed of the disc loading operation
12
AG-OK
O
Output of aging status in test mode “L”: under aging, “H”: aging completed Not used (open)
13
ADJ-OK
O
Output of status when aging completed in test mode “L”: aging NG, “H”: aging OK
Not used (open)
14 to 17
NCO
O
Not used (open)
18
DFCTSEL
I
Select whether defect function is used for the CXD2652AR (IC301)
“L”: used this function , “H”: not used this function (fixed at “H” in this set)
19
DPLLSEL
I
Select whether digital PLL function is used for the CXD2652AR (IC301)
“L”: used this function , “H”: not used this function (fixed at “H” in this set)
20
EMPHSEL
I
Select whether emphasis signal output from pin or unilink data
“L”: outputs from both pin and unilink data, “H”: output from pin only (fixed at “H” in this set)
21
LOCK
O
Mini-disc lock detection signal output terminal “H”: lock
22
NCO
O
Not used (open)
23
2M/4M
I
Select whether D-RAM capacitance 2M bit or 4M bit “L”: 4M bit (external D-RAM) , “H”: 2M
bit (internal D-RAM of CXD2652AR) (fixed at “L” in this set)
24, 25
NCO
O
Not used (open)
26
MNT0
I
Focus OK signal input from the CXD2652AR (IC301)
“H” is input when focus is on (“L”: NG)
27
MNT1
I
Track jump detection signal input from the CXD2652AR (IC301)
28
MNT2
I
Busy monitor signal input from the CXD2652AR (IC301)
29
MNT3
I
Spindle servo lock status monitor signal input from the CXD2652AR (IC301)
30
RESET
I
System reset signal input from the master controller (IC502), reset signal generator (IC503) and
reset switch (S101) “L”: reset
For several hundreds msec. after the power supply rises, “L” is input, then it changes to “H”
31
EXTAL
O
Main system clock output terminal (10 MHz)
32
XTAL
I
Main system clock input terminal (10 MHz)
33
VSS
—
34
TX
O
Sub system clock output terminal (32.768 kHz) Not used (open)
35
TEX
I
Sub system clock input terminal (32.768 kHz) Not used (fixed at “L”)
36
AVSS
—
37
AVREF
I
Reference voltage input terminal (+5V) (for A/D converter)
38
INIT
I
Initial reset signal input terminal (A/D input) (fixed at “H”)
39
TEMP
I
Temperature sensor (TH501) input terminal (A/D input)
40
ACNT
I
Select the number of load/eject aging times (A/D input)
0H – 54H (30 times), 55H – OA9H (20 times), OAAH – OFFH (10 times)
41
DO-SEL
I
Select the digital output bits (A/D input)
42
EE-CS
O
Chip select signal output to the external EEPROM device Not used (open)
43
EE-CKO
O
Serial data transfer clock signal output to the external EEPROM device Not used (open)
44
EE-SIO
I/O
Two way data bus with the external EEPROM device Not used (open)
45
MD-SO
O
Writing serial data signal output to the CXD2652AR (IC301) and CXA2523AR (IC302)
Not used (open)
Not used
Ground terminal
Ground terminal (for A/D converter)
51
Pin No.
Pin Name
I/O
46
LINKOFF
O
Unilink on/off control signal output for the SONY bus “L”: link on, “H”: link off Not used
Description
47
UNIREQ
O
Data request signal output terminal (for SONY bus) “H”: request on Not used (open)
48
UNICKIO
I/O
Serial clock signal input from the master controller (IC502) or serial clock signal output to the
SONY bus interface (IC601) and liquid crystal display drive controller (IC701) (for SONY bus)
49
UNISI
I
Serial data input from the SONY bus interface (IC601)
50
UNISO
O
Serial data output to the SONY bus interface (IC601)
51
MD-CKO
O
Serial data transfer clock signal output to the CXD2652AR (IC301) and CXA2523AR (IC302)
52
MD-SI
I
Reading serial data signal input from the CXD2652AR (IC301)
53
NCO
O
Not used (open)
54
SENS
I
Internal status (SENSE) input from the CXD2652AR (IC301)
55
CC-XINT
I
Interrupt status input from the CXD2652AR (IC301)
56
LIMIT-IN
I
Detection input from the sled limit-in detect switch
The optical pick-up is inner position when “L”
57
EJT-KEY
I
Eject request signal input terminal “L”: eject on Not used (fixed at “H”)
58
ERROR-PWM
O
PWM error monitor output terminal (C1and ATER is output when test mode) Not used (open)
59
MD-RST
O
Reset signal output to the CXD2652AR (IC301) and BH6511FS (IC303) “L”: reset
60
BU-IN
I
Battery detect signal input from the SONY bus interface (IC601) and battery check circuit
“H”: battery on
61
BUS-ON
I
SONY bus on/off control signal input from the master controller (IC502) “L”: bus on
62
SQSY
I
Subcode Q sync (SCOR) input from the CXD2652AR (IC301)
“L” is input every 13.3 msec Almost all, “H” is input
63
C-SW
I
Inputs the disc loading start or disc eject completion detect switch detection signal
“L”: When start or eject completed of the disc loading operation
64
MD-LAT
O
Serial data latch pulse signal output to the CXD2652AR (IC301) and CXA2523AR (IC302)
65
MD-ON
O
Power supply on/off control signal output of the MD mechanism deck section main power supply
“H”: power on
66
DEEMP
O
Emphasis on/off control signal output to the master controller (IC502) “H”: emphasis on
67
A-MUTE
O
Audio muting on/off control signal output terminal “H”: muting on
68
NCO
O
Not used (open)
69
TSTCKO
O
Output of clock signal for the test mode display Not used (open)
70
TSTSO
O
Output of data for the test mode display Not used (open)
71
TSTMOD
I
Setting terminal for the test mode “L”: test mode, “H”: normal mode
72
VCC
—
73
NIL
I
Not used (fixed at “H”)
74 to 77
TOUT0 to TOUT3
O
Output of the 4×8 matrix test keys
78 to 80
TIN0 to TIN2
I/O
Input of the 4×8 matrix test keys (“L” is always output, except in test mode)
Power supply terminal (+5V)
*1 Loading motor (M903) control
Operation
IN
OUT
BRAKE
STOP
LOAD (pin 6)
“H”
“L”
“H”
“L”
EJECT (pin 7)
“L”
“H”
“H”
“L”
Terminal
52
Not used (open)
Not used (open)
• MAIN BOARD IC502 (MASTER CONTROLLER)
MB90574BPMT-G-263-BND (MDX-C8500X) MB90574BPMT-G-264-BND (MDX-C8500R)
Pin No.
Pin Name
I/O
Description
1
NC
I
Not used (fixed at “L”)
2
AMSIN
I
Input terminal of whether a music is present or not is detected at auto music sensor
“L”: music is not present, “H”: music is present Not used (fixed at “L”)
3
AMSON
O
Tape auto music sensor control signal output terminal
“L” is output to lower the gain for audio level at FF/REW mode Not used (open)
4
SA LAT
O
Serial data latch pulse output for spectrum analyzer section to the liquid crystal display drive
controller (IC701)
5
ATT
O
Audio line muting on/off control signal output terminal “H”: muting on
6
SYSRST
O
System reset signal output to the MD mechanism controller (IC501), liquid crystal display drive
controller (IC701) and SONY bus interface (IC601) “L”: reset
7
F/R
O
Tape detection signal output terminal “L”: reverse side, “H”: forward side Not used (open)
8
VCC
—
Power supply terminal (+5V)
9
MTLIN
I
10
T.ROM-SDA
I/O
Two-way data bus for tuner EEPROM with the FM/AM tuner unit (TUX201)
11
T.ROM-SCL
O
Tuner EEPROM bus clock signal output to the FM/AM tuner unit (TUX201)
12
RX
I
Input terminal at the flash memory data write mode
Front panel open/close detection signal input terminal
“L” is input when the front panel is closed
13
TX
O
Output terminal at the flash memory data write mode
Display serial data output to the liquid crystal display driver (IC901)
14
BUS-ON
O
Bus on/off control signal output to the MD mechanism controller (IC501), liquid crystal display
drive controller (IC701) and SONY bus interface (IC601) “L”: bus on
15
BEEP
O
Beep sound drive signal output terminal
16
NC
O
Not used (open)
Auto metal detection signal input terminal
Not used (fixed at “L”)
17
UNISI
I
Serial data input from the SONY bus interface (IC601)
18
UNISO
O
Serial data output to the SONY bus interface (IC601)
19
UNICKO
O
Serial clock signal output to the MD mechanism controller (IC501), liquid crystal display drive
controller (IC701) and SONY bus interface (IC601)
20
IF-BW
I
Tuner wide/narrow select signal input terminal “L”: wide, “H”: narrow
Not used (fixed at “L”)
21
SW SHIFT
O
Not used
22, 23
NC
O
Not used (open)
24
SIRCS
I
Sircs remote control signal input from the remote control receiver (IC951)
25
DSPSI
I
Serial data input from the CXD2726Q (IC805)
26
DSPSO
O
Serial data output to the CXD2726Q (IC805)
27
DSPCKO
O
Serial data transfer clock signal output to the CXD2726Q (IC805) and liquid crystal display drive
controller (IC701)
28
DSPPLL
O
PLL clock control signal output to the CXD2726Q (IC805)
At “L” is output: fixed at “L” is PLCLK (pin ia of IC805 CXD2726Q)
At “H” is output: PLL clock signal output to the PLCLK (pin ia of IC805 CXD2726Q)
29
DSPMST
O
Bit clock (BCK) and L/R sampling (LRCK) signal master/slave mode selection signal output to
the CXD2726Q (IC805) “L”: master mode, “H”: slave mode
30
NC
O
Not used (open)
31
VOLATT
O
Pre amplifier muting on/off control signal output to the electrical volume (IC301)
“L”: muting on
32
TUMUTE
O
Muting on/off control signal output of the FM/AM tuner signal “L”: muting on
33
VSS
—
Ground terminal
34
C
—
Connected to coupling capacitor for the power supply Not used (open)
53
Pin No.
Pin Name
I/O
35
DSPLAT
O
Serial data latch pulse output to the CXD2726Q (IC805)
36
DSPRST
O
Reset signal output to the CXD2726Q (IC805) “L”: reset
37
ANT CUT
O
Tuner system power supply on/off control signal output terminal “H”: tuner power on
Not used (open)
38
DVCC
—
Power supply terminal (+5V) (for D/A converter)
39
DVSS
—
Ground terminal (for D/A converter)
40, 41
NC
O
Not used (open)
42
AVCC
—
43
AVRH
I
Reference voltage (+5V) input terminal (for A/D converter)
44
AVRL
I
Reference voltage (0V) input terminal (for A/D converter)
45
AVSS
—
54
Description
Power supply terminal (+5V) (for analog system)
Ground terminal (for analog system)
46
KEYIN0
I
Key input terminal (A/D input) (LSW901 to LSW908, S901 to S904)
OFF, SOURCE, SOUND EQ, MENU, PTY DSPL (MDX-C8500R), DSPL (MDX-C8500X),
LIST, ENTER, MODE, SEEK/AMS - . m + > M, DISC/PRST +, PRST/DISC - keys
input
47
KEYIN1
I
Key input terminal (A/D input) (LSW751, LSW909 to LSW917)
Z, DSO, TA, AF, 6 to 3 SHUF 2, REP 1 keys input
(LSW910 TA, LSW911 AF: MDX-C8500R ONLY)
48
RCIN0
I
Rotary remote commander key input terminal (A/D input)
49
DSTSEL
I
Destination setting terminal (A/D input) “L”: MDX-C8500X/C8500R (TYPE A),
“M”: MDX-C8500R (TYPE C), “H”: MDX-C8500R (TYPE B)
50
QUALITY
I
Noise level detection signal input at SEEK mode (A/D input)
51
FMAGC
I
FM AGC detection signal input from the FM/AM tuner unit (TUX201) (A/D input)
52
MTP
I
Multi-path detection signal input from the RDS decoder (IC201) (A/D input)
Used for the MDX-C8500R only (MDX-C8500X: Not used open))
53
VSM
I
FM and AM signal meter voltage detection input from the FM/AM tuner unit (TUX201)
(A/D input)
54
VCC
—
Power supply terminal (+5V)
55
AMPON
O
Standby on/off control signal output terminal
“L”: standby mode, “H”: amplifier on
56
NS-MASK
O
Discharge control signal output for the noise detection circuit “H”: discharge
Used for the MDX-C8500R only (MDX-C8500X: Not used open))
57
MTLOUT
O
METAL output terminal (METAL on at “L” output) Not used (open)
58
REEL
I
Rotation detect signal input terminal Not used (fixed at “L”)
59
POS0
I
60
POS1
I
61
POS2
I
62
POS3
I
63
VSS
—
64
NC
I
Not used (fixed at “L”)
65
F OSC
I
Frequency count terminal from power control (IC302)
66
LM-LOD
O
Loading motor control signal output terminal “H” active
(For the loading direction and forward side operation) Not used (open)
67
CM ON
O
Capstan/reel motor control signal output terminal “H”: motor on Not used (open)
68
TAPE ON
O
Tape system power supply on/off control signal output terminal “H”: tape on Not used (open)
69
FLASH-W
I
Internal flash memory data write mode detection signal input terminal Not used
70
I2C SDA
I/O
Two-way data I2C bus with the FM/AM tuner unit (TUX201), RDS decoder (IC201) and
electrical volume (IC301) (RDS decoder is MDX-C8500R only)
71
I2C CKO
O
I2C bus clock signal output to the FM/AM tuner unit (TUX201), RDS decoder (IC201) and
electrical volume (IC301) (RDS decoder is MDX-C8500R only)
Tape position (EJECT/FF/REW/REV/
FWD mode) detect input from the tape
operation switch on the deck mechanism
Not used this function (fixed at “L”)
POS0: “L”: EJECT mode, “H”: others mode
POS1: “L”: FF and FWD mode, “H”: others mode
POS2: “L”: REW mode, “H”: others mode
POS3: “L”: REV and EJECT mode, “H”: others mode
Ground terminal
Pin No.
Pin Name
I/O
Description
72
RCIN1
I
Rotary remote commander shift key input terminal
73
X1A
O
Sub system clock output terminal (32.768 kHz)
74
X0A
I
Sub system clock input terminal (32.768 kHz)
75
DAVN
I
Data transmit completed detection signal input from the RDS decoder (IC201) “L” active
Used for the MDX-C8500R only (MDX-C8500X: Not used open))
76
CDMD ON
I
CD/MD on/off control signal input from the MD mechanism controller (IC501)
77
BU-IN
I
Battery detection signal input from the SONY bus interface (IC601) and battery detect circuit
“L” is input at low voltage
78
DSPREADY
I
Transfer enable signal input from the CXD2726Q (IC805)
“L”: transfer prohibition , “H”: transfer permission
79
KEYACK
I
Input of acknowledge signal for the key entry Acknowledge signal is input to accept function
and eject keys in the power off status On at input of “H”
80
AD ON
O
A/D converter power control signal output terminal
When the KEYACK (pin ul) that controls reference voltage power for key A/D conversion input
is active, “L” is output from this terminal to enable the input
81
ACCIN
I
Accessory detection signal input terminal “L”: accessory on
82
FLASH ON
O
Power on/off control signal output of the illumination LED and liquid crystal display driver
(IC901) “H”: power on
83
PW-ON
O
Main system power supply on/off control signal output terminal “H”: power on
84
TESTIN
I
Setting terminal for the test mode “L”: test mode, Normally: fixed at “H”
85
RAMBU
I
Internal RAM reset detection signal input from the RN5VD33AA (IC504)
Input terminal to check that RAM data are not destroyed due to low voltage
This checking is made within 100 msec after reset
86
HSTX
I
Hardware standby input terminal “L”: hardware standby mode
87
MD2
I
Setting terminal for the CPU operational mode (fixed at “L” in this set)
88
MD1
I
Setting terminal for the CPU operational mode (fixed at “H” in this set)
89
MD0
I
Setting terminal for the CPU operational mode (fixed at “H” in this set)
90
RESET
I
System reset signal input from the reset signal generator (IC503) and reset switch (S101)
“L”: reset “L” is input for several 100 msec after power on, then it changes to “H”
91
VSS
—
92
X0
I
Main system clock input terminal (3.68 MHz)
93
X1
O
Main system clock output terminal (3.68 MHz)
94
VCC
—
Power supply terminal (+5V)
95
ILLIN
I
Auto dimmer control illumination line detection signal input terminal
“L” is input at dimmer detection
96
TELATT
I
Telephone detection signal input terminal
97
EMPH
I
Emphasis control signal input from the MD Mechanism controller (IC501)
Reset signal input in this set
Ground terminal
At input of “H”, the signal is attenuated by –20 dB
98
F CH
O
Frequency changing terminal from the power control (IC302) “H”: frequency change
99 to 102
NC
O
Not used (open)
103
4V SEL
I
Input terminal of whether line driver is mounted or not is detected
“L”: line driver is not mounted (MDX-C8500R), “H”: line driver is mounted (MDX-C8500X)
104
COL SEL
I
Setting terminal for the illumination color
“L”: 2 color (MDX-C8500R), “H”: 1 (red) color (MDX-C8500X)
105
AMPATT
O
Power amplifier muting on/off control signal output terminal “H”: muting on
106
BOOT
O
Serial data output to the liquid crystal display drive controller (IC701)
107
DSP GAIN
O
Not used (open)
108
NC
O
Not used (open)
109
XR CDMD
I
Setting terminal for the internal mechanism tape or CD/MD
“L”: tape, “H”: CD/MD (fixed at “H” in this set)
110
DSP ON
O
Power supply on/off control signal output for the CXD2726Q (IC805) “H”: DSP on
55
Pin No.
Pin Name
I/O
111
CD MD
I
Setting terminal for the internal mechanism CD or MD
“L”: CD, “H”: MD (fixed at “H” in this set)
112
NC
I
Not used (fixed at “L”)
113
TUNON
O
Tuner system power supply on/off control signal output terminal
“H”: tuner power on
114
NC
I
Not used (fixed at “L”)
115
REIN1
I
Dial pulse input of the rotary encoder (RE901) (A phase input)
(for VOLUME/BASS/TREBLE/BALANCE/FADER control)
116
REIN0
I
Dial pulse input of the rotary encoder (RE901) (B phase input)
(for VOLUME/BASS/TREBLE/BALANCE/FADER control)
117
NOSE-SW
I
Front panel block remove/attach detection signal input from the nose detection switch (S102)
“L”: front panel is attached
118
DOORIND
O
LED drive signal output of the MD disc slot illumination and Z indicator (LED751, LSW751)
“H”: LED on “H” is output to turn on LED when front panel is opened
119
VSS
—
Ground terminal
120
DOLBY
O
Dolby control terminal “H”: dolby on Not used (open)
56
Description
• DSO BOARD IC805 CXD2726Q-4 (DIGITAL SIGNAL PROCESSOR, DIGITAL FILTER, D/A CONVERTER)
Pin No.
Pin Name
I/O
1
VSS1
—
Description
Ground terminal (digital system)
2 to 15
T.P
I
Input terminal for the test (fixed at “L”)
16 to 21
TST0 to TST5
I
Input terminal for the test (fixed at “L”)
22 to 24
JPE1 to JPE3
I
External condition jump terminal “H”: condition jump (fixed at “L”)
25
VDD1
—
Power supply terminal (+3.3V) (digital system)
26
AVS3
—
Ground terminal (for D/A converter 1) (analog system)
27
AOUTL1
O
D/A converter 1 (L-ch side) output terminal
Analog signal output for front side (L-ch side) output in this set
28
AVD3
—
Power supply terminal (+3.3V) (for D/A converter 1) (analog system)
29
AOUTR1
O
D/A converter 1 (R-ch side) output terminal
Analog signal output for rear side (L-ch side) output in this set
30
AVD5
—
Power supply terminal (+3.3V) (for D/A converter 1) (analog system)
31
AVS5
—
Ground terminal (for D/A converter 1) (analog system)
32
AVD1
—
Power supply terminal (+3.3V) (for L-ch side A/D converter) (analog system)
33
AVS1
—
Ground terminal (for L-ch side A/D converter) (analog system)
34
LREF
O
Connected to the bus control for A/D converter (for L-ch side)
35
LIN
I
A/D converter (L-ch side) analog input terminal
Tuner and bus audio input signal (L-ch side) in this set
36
AVS7
—
Ground terminal (for D/A converter 2) (analog system)
37
AVD7
—
Power supply terminal (+3.3V) (for D/A converter 2) (analog system)
38
AOUTL2
O
D/A converter 2 (L-ch side) output terminal Not used (open)
39
AVDX
—
Power supply terminal (+3.3V) (for master clock) (analog system)
40
XTLO38
O
System clock output terminal (16.9344 MHz)
41
XTLI38
I
System clock input terminal (16.9344 MHz)
42
AVSX
—
Ground terminal (for master clock) (analog system)
43
AOUTR2
O
D/A converter 2 (R-ch side) output terminal
Analog signal output for sub woofer output in this set
44
AVD8
—
Power supply terminal (+3.3V) (for D/A converter 2) (analog system)
45
AVS8
—
Ground terminal (for D/A converter 2) (analog system)
46
RIN
I
A/D converter (R-ch side) analog input terminal
Tuner and bus audio input signal (R-ch side) in this set
47
RREF
O
Connected to the bus control for A/D converter (for R-ch side)
48
AVS2
—
Ground terminal (for R-ch side A/D converter) (analog system)
49
AVD2
—
Power supply terminal (+3.3V) (for R-ch side A/D converter) (analog system)
50
AVS6
—
Ground terminal (for D/A converter 3) (analog system)
51
AVD6
—
Power supply terminal (+3.3V) (for D/A converter 3) (analog system)
52
AOUTL3
O
D/A converter 3 (L-ch side) output terminal
Analog signal output for rear side (R-ch side) output in this set
53
AVD4
—
Power supply terminal (+3.3V) (for D/A converter 3) (analog system)
54
AOUTR3
O
D/A converter 3 (R-ch side) output terminal
Analog signal output for front side (R-ch side) output in this set
55
AVS4
—
Ground terminal (for D/A converter 3) (analog system)
56
VSS2
—
Ground terminal (digital system)
57
XRST
I
System reset signal input from the master controller (IC502) “L”: reset
58
BFOT
O
Master clock signal output terminal Not used (open)
59
SCK
I
Serial data transfer clock signal input from the master controller (IC502) and liquid crystal display
drive controller (IC701)
57
Pin No.
Pin Name
I/O
Description
60
REDY
O
Transfer enable signal output to the master controller (IC502)
“L”: transfer prohibition
61
TRDT
O
Serial data output to the master controller (IC502) and liquid crystal display drive controller
(IC701)
62
XLAT
I
Serial data latch pulse input from the master controller (IC502)
63
RVDT
I
Serial data input from the master controller (IC502)
64
XS24
I
Serial data 24/32 bit slot selection signal input terminal
“L”: 24 bit slot, “H”: 32 bit slot (validity at slave mode) (fixed at “H” in this set)
65
VDD2
—
Power supply terminal (+3.3V) (digital system)
66
VSS3
—
Ground terminal (digital system)
67 to 69
SO1 to SO3
O
Serial data output terminal
Not used (open)
70
SOUT
O
Serial data output terminal
Not used (open)
71
SI1
I
Serial data input from the CXD2652AR (IC301)
72, 73
SI2, SI3
I
Serial data input terminal
Not used (fixed at “L”)
74
SIN
I
Serial data input terminal
Not used (fixed at “L”)
75
BCK
I
Bit clock signal (2.8224 MHz) input from the CXD2652AR (IC301)
76
LRCK
I
L/R sampling clock signal (44.1 kHz) input from the CXD2652AR (IC301)
77
XMST
I
Bit clock (BCK) and L/R sampling clock (LRCK) signal master/slave mode selection signal input
from the master controller (IC502) “L”: master mode, “H”: slave mode
78
VDD3
—
Power supply terminal (+3.3V) (digital system)
79
AVSP
—
Ground terminal (PLL system)
80
XPLLEN
I
PLL enable signal input terminal
81
PLCLK
O
PLL clock signal output terminal (22.5792 MHz)
82
XECKSTP
I
PLL clock output control signal input from the master controller (IC502)
At “L” is input: fixed at “L” is PLCLK (pin ia)
At “H” is input: PLL clock signal output from the PLCLK (pin ia)
83
AVDP
—
Power supply terminal (+3.3V) (PLL system)
Ground terminal (digital system)
Normally: fixed at “L”
84
VSS4
—
85 to 94
T.P
I
95
VDD4
—
Power supply terminal (+3.3V) (digital system)
96
AVSD
—
Ground terminal (for D-RAM)
97 to 99
T.P
I
100
AVDD
—
58
Input terminal for the test
Input terminal for the test
Normally: fixed at “L”
Normally: fixed at “L”
Power supply terminal (+3.3V) (for D-RAM)
SECTION 6
EXPLODED VIEWS
NOTE:
• -XX and -X mean standardized parts, so they
may have some difference from the original
one.
• Color Indication of Appearance Parts
Example:
KNOB, BALANCE (WHITE) . . . (RED)
↑
↑
Parts Color Cabinet's Color
(1)
• Items marked “*” are not stocked since they
are seldom required for routine service. Some
delay should be anticipated when ordering
these items.
• The mechanical parts with no reference number in the exploded views are not supplied.
• Hardware (# mark) list and accessories and
packing materials are given in the last of the
electrical parts list.
• Please refer to servicing notes (page 3) for system of TYPE A, B and C.
#4
GENERAL SECTION
#3
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
13
14
17
B
#3
11
F1
27
MG-164NV-138
#10
#10
15
12
24
#2
#10
#3
25
26
A
23
2
9
TUX201
16
21
not
supplied
#4
22
3
7
4
8
B
A
5
#4
6
#10
18
#1
#12
#10
#1
Front panel section
19
#10
1
Part No.
Description
Ref. No.
Part No.
1
2
3
4
5
X-3378-458-2
X-3376-699-2
3-030-909-02
3-713-786-51
3-034-086-01
PANEL ASSY, SUB
GEAR ASSY
DAMPER, OIL
SCREW +P 2X3
SPRING (DOOR)
* 15
* 16
17
6
7
* 8
* 9
* 9
3-033-750-02
3-040-990-01
1-677-865-11
A-3294-906-A
A-3294-915-A
DOOR (MD)
BUTTON (EJECT) (Z)
SUB BOARD
MAIN BOARD, COMPLETE (C8500X)
MAIN BOARD, COMPLETE (C8500R: TYPE A)
* 18
3-040-996-01 HEAT SINK (2P)
3-045-878-01 PLATE (TU), GROUND
1-776-527-71 CORD (WITH CONNECTOR) (ISO) (POWER)
(C8500R)
1-792-194-11 CORD (WITH CONNECTOR) (POWER)
(C8500X)
3-040-994-21 CHASSIS
* 9
* 9
11
* 12
* 13
A-3294-918-A
A-3294-919-A
3-376-464-11
3-040-998-01
3-041-017-01
MAIN BOARD, COMPLETE (C8500R: TYPE B)
MAIN BOARD, COMPLETE (C8500R: TYPE C)
SCREW (+PTT 2.6X6), GROUND POINT
BRACKET (IC)
BRACKET (MD)
19
* 21
* 22
23
* 24
X-3377-621-2
3-045-877-01
3-047-865-01
1-792-602-11
3-041-261-01
LOCK ASSY
CUSHION (TU)
SHEET (MAIN), INSULATING
CORD (WITH CONNECTOR) (SUB OUT)
BRACKET (TR)
* 14
3-040-995-01 COVER
* 25
* 26
* 27
F1
TUX201
A-3294-916-A
3-045-994-01
3-045-138-01
1-532-877-11
A-3320-738-A
DSO BOARD, COMPLETE
COVER (DSP), SHIELD
CASE (DSP), SHIELD
FUSE (BLADE TYPE) (AUTO FUSE) (10A)
TUNER UNIT (TUX-020)
Ref. No.
Remark
17
Description
Remark
59
(2)
FRONT PANEL SECTION
#13
not supplied
(KEY board)
70
56
55
64
59
63
62
53
61
54
60
66
LCD901
65
67
52
68
69
(C8500R)
51
Ref. No.
Part No.
Description
51
52
53
54
55
3-041-010-01
3-040-987-01
3-040-986-01
3-041-003-01
3-040-980-01
BUTTON (1-6/M) (MODE. 1. 2. 3. 4. 5. 6)
BUTTON (OFF)
BUTTON (MENU/SOUND)
BUTTON (LIST/ENTER) (DSPL. LIST. ENTER)
BUTTON (SOURCE)
56
* 59
60
* 61
* 62
3-042-458-01
3-040-997-01
1-694-660-11
3-041-371-02
3-040-993-01
KNOB (VOL-DSO)
PLATE (LCD), GROUND
CONDUCTIVE BOARD, CONNECTION
SHEET (REFLECTOR)
PLATE (LCD), LIGHT GUIDE
* 63
3-040-992-02 HOLDER (LCD)
60
Remark
Ref. No.
Part No.
Description
Remark
64
65
66
67
68
X-3378-398-1
3-935-151-01
3-040-989-01
3-041-005-11
3-041-006-01
PANEL ASSY, FRONT BACK
SPRING (OPEN)
BUTTON (OPEN)
BUTTON (D) (D-BASS)
BUTTON (AF/TA) (C8500R)
69
69
70
LCD901
LCD901
X-3379-021-1
X-3379-022-1
3-045-596-01
1-803-915-11
1-803-915-21
PANEL SUB ASSY (C8500R)
PANEL SUB ASSY (C8500X)
CUSHION (OFF)
DISPLAY PANEL, LIQUID CRYSTAL (C8500R)
DISPLAY PANEL, LIQUID CRYSTAL (C8500X)
(3)
MECHANISM DECK SECTION-1
(MG-164NV-138)
112
#8
113
114
106
#6
111
107
109
115
109
110
116
109
117
118
105
#6
#6
#6
111
104
105
108
103
103
104
102
101
#5
Ref. No.
Part No.
Description
SERVO BOARD, COMPLETE
CHASSIS ASSY, MD
SPRING (FLOAT F), TENSION
SPRING (FLOAT B), TENSION
DAMPER, OIL
* 110
111
* 112
113
* 114
3-032-712-01
3-919-281-01
X-3376-800-1
3-035-932-01
X-3376-797-3
LEVER (LOCK R)
SPRING (CHUCKING)
COVER ASSY, MD
WASHER, STOPPER
LEVER (LE) ASSY
HOLDER ASSY
SPRING (HOLDER)
CUSHION (EJ2)
CUSHION (EJ3)
115
116
* 117
* 118
3-032-707-01
3-925-034-01
X-3376-798-1
3-032-711-01
SPRING (LEVER LE)
ROLLER (GEAR E)
ARM ASSY, CHUCKING
LEVER (LOCK L)
Ref. No.
Part No.
Description
* 101
* 102
103
104
105
A-3326-039-A
X-3376-799-1
3-032-714-02
3-921-111-01
3-919-273-01
* 106
107
* 108
* 109
X-3376-796-3
3-032-682-01
3-034-301-01
3-034-302-01
Remark
Remark
61
(4)
MECHANISM DECK SECTION-2
(MG-164NV-138)
157
158
M903
159
M901
156
#9
#7
155
161
#9
162
160
#8
M902
164
163
#8
154
165
#7
152
153
166
151
The components identified by mark 0 or dotted
line with mark 0 are critical for safety.
Replace only with part number specified.
Ref. No.
Part No.
Description
151
152
153
154
* 155
2-626-617-01
A-3326-037-A
1-654-693-11
3-919-283-01
3-032-704-01
SCREW (2X8)
SENSOR BOARD, COMPLETE
SENSOR FLEXIBLE BOARD
BRACKET (SL)
BASE (SL)
156
157
158
159
* 160
3-919-297-01
A-3301-750-A
3-032-660-01
3-032-669-01
3-032-705-01
BRACKET (SP)
CHASSIS (OP) ASSY
BRACKET (LO)
SPRING (RACK), TENSION
BEARING (SL)
62
Remark
Ref. No.
Part No.
Description
161
162
163
164
0 165
X-3373-213-1
3-939-590-07
3-010-091-01
3-919-293-01
8-583-065-03
SCREW ASSY, FEED
SCREW (IB LOCK)
SPRING (SL FEED)
SHAFT (OPT S), GUIDE
OPTICAL PICK-UP KMS-241C/J1RP
3-920-537-01
A-3301-407-A
A-3291-190-A
A-3291-191-A
SHAFT (OPT L), GUIDE
MOTOR ASSY, SP (SPINDLE)
MOTOR ASSY, SL (SLED)
MOTOR ASSY, LO (LOADING)
166
M901
M902
M903
Remark
SECTION 7
ELECTRICAL PARTS LIST
NOTE:
• Due to standardization, replacements in the
parts list may be different from the parts specified in the diagrams or the components used
on the set.
• -XX and -X mean standardized parts, so they
may have some difference from the original
one.
• RESISTORS
All resistors are in ohms.
METAL: Metal-film resistor.
METAL OXIDE: Metal oxide-film resistor.
F: nonflammable
• Please refer to servicing notes (page 3) for
system of TYPE A, B and C.
DSO
• Items marked “*” are not stocked since they
are seldom required for routine service.
Some delay should be anticipated when ordering these items.
• SEMICONDUCTORS
In each case, u: µ, for example:
uA. . : µA. .
uPA. . : µPA. .
uPB. . : µPB. .
uPC. . : µPC. .
uPD. . : µPD. .
• CAPACITORS
uF: µF
• COILS
uH: µH
Description
Remark
Part No.
When indicating parts by reference
number, please include the board.
Ref. No.
Part No.
*
A-3294-916-A DSO BOARD, COMPLETE
********************
C842
C843
1-126-394-11 ELECT CHIP
1-126-394-11 ELECT CHIP
10uF
10uF
20%
20%
16V
16V
*
3-045-138-01 CASE (DSP), SHIELD
C844
C845
C846
C847
C848
1-115-412-11
1-126-394-11
1-115-412-11
1-115-412-11
1-115-412-11
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
680PF
10uF
680PF
680PF
680PF
5%
20%
5%
5%
5%
25V
16V
25V
25V
25V
C849
C850
C851
C852
C853
1-115-412-11
1-115-412-11
1-115-412-11
1-115-412-11
1-115-412-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
680PF
680PF
680PF
680PF
680PF
5%
5%
5%
5%
5%
25V
25V
25V
25V
25V
C854
C855
C856
C857
C861
1-115-412-11
1-107-826-11
1-107-826-11
1-107-826-11
1-126-394-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
680PF
0.1uF
0.1uF
0.1uF
10uF
5%
10%
10%
10%
20%
25V
16V
16V
16V
16V
C862
C874
C875
C876
C877
1-107-826-11
1-164-230-11
1-164-230-11
1-164-230-11
1-164-230-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
220PF
220PF
220PF
220PF
10%
5%
5%
5%
5%
16V
50V
50V
50V
50V
C878
C879
C880
C881
1-164-230-11
1-164-230-11
1-125-838-11
1-125-838-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
220PF
220PF
2.2uF
2.2uF
5%
5%
10%
10%
50V
50V
6.3V
6.3V
< CAPACITOR >
Ref. No.
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
Description
Remark
C801
C802
C803
C804
C805
1-126-393-11
1-126-392-11
1-126-394-11
1-117-709-11
1-107-826-11
ELECT CHIP
ELECT CHIP
ELECT CHIP
ELECT CHIP
CERAMIC CHIP
33uF
100uF
10uF
10uF
0.1uF
20%
20%
20%
20%
10%
10V
6.3V
16V
10V
16V
C806
C808
C809
C810
C811
1-107-826-11
1-162-924-11
1-162-917-11
1-128-993-21
1-128-993-21
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
ELECT CHIP
0.1uF
56PF
15PF
22uF
22uF
10%
5%
5%
20%
20%
16V
50V
50V
10V
10V
C812
C813
C814
C815
C816
1-107-826-11
1-107-826-11
1-107-826-11
1-107-826-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
10%
10%
10%
10%
10%
16V
16V
16V
16V
16V
C817
C818
C819
C820
C821
1-107-826-11
1-107-826-11
1-125-838-11
1-107-826-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
2.2uF
0.1uF
0.1uF
10%
10%
10%
10%
10%
16V
16V
6.3V
16V
16V
C822
C823
C824
C825
C826
1-128-415-11
1-107-826-11
1-126-393-11
1-107-826-11
1-126-392-11
ELECT CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
ELECT CHIP
68uF
0.1uF
33uF
0.1uF
100uF
20%
10%
20%
10%
20%
10V
16V
10V
16V
6.3V
C827
C828
C829
C830
C831
1-107-826-11
1-107-826-11
1-107-826-11
1-107-826-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
10%
10%
10%
10%
10%
16V
16V
16V
16V
16V
C834
C835
C836
C837
C838
1-107-826-11
1-107-826-11
1-107-826-11
1-107-826-11
1-162-965-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.1uF
0.0015uF
10%
10%
10%
10%
10%
16V
16V
16V
16V
50V
FB801
FB803
FB804
FB805
FB806
1-414-235-22
1-500-329-21
1-500-329-21
1-500-329-21
1-500-329-21
C839
C840
C841
1-107-826-11 CERAMIC CHIP
1-126-394-11 ELECT CHIP
1-126-394-11 ELECT CHIP
0.1uF
10uF
10uF
10%
20%
20%
16V
16V
16V
FB807
FB808
FB809
1-500-329-21 FERRITE BEAD INDUCTOR CHIP
1-500-329-21 FERRITE BEAD INDUCTOR CHIP
1-414-760-21 FERRITE BEAD INDUCTOR CHIP
< CONNECTOR >
CN801
1-794-320-11 PIN, CONNECTOR (PC BOARD) 29P
< DIODE >
D802
D804
8-719-073-01 DIODE MA111-TX
8-719-421-82 DIODE MA8043-M (TX)
< FERRITE BEAD >
FERRITE BEAD INDUCTOR CHIP
FERRITE BEAD INDUCTOR CHIP
FERRITE BEAD INDUCTOR CHIP
FERRITE BEAD INDUCTOR CHIP
FERRITE BEAD INDUCTOR CHIP
63
DSO
Ref. No.
KEY
Part No.
Part No.
Description
R839
R840
R841
R842
1-216-831-11
1-216-841-11
1-216-841-11
1-216-831-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
6.8K
47K
47K
6.8K
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
< IC >
R843
R844
R845
R846
R847
1-216-833-11
1-216-841-11
1-216-831-11
1-216-833-11
1-216-833-11
RES, CHIP
METAL CHIP
METAL CHIP
RES, CHIP
RES, CHIP
10K
47K
6.8K
10K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
IC
IC
IC
IC
IC
R848
R849
R850
R851
R852
1-216-841-11
1-216-831-11
1-216-833-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
RES, CHIP
RES, CHIP
RES, CHIP
47K
6.8K
10K
10K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R853
R854
R855
R856
R857
1-216-833-11
1-216-833-11
1-216-833-11
1-216-833-11
1-216-833-11
RES, CHIP
RES, CHIP
RES, CHIP
RES, CHIP
RES, CHIP
10K
10K
10K
10K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R858
R859
R860
R861
R862
1-216-833-11
1-216-833-11
1-216-833-11
1-216-833-11
1-216-797-11
RES, CHIP
RES, CHIP
RES, CHIP
RES, CHIP
METAL CHIP
10K
10K
10K
10K
10
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R863
R864
R865
R868
R870
1-216-797-11
1-216-797-11
1-216-864-11
1-216-864-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10
10
0
0
1K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R874
R875
R876
R877
R878
1-216-828-11
1-216-828-11
1-216-828-11
1-216-828-11
1-216-828-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
3.9K
3.9K
3.9K
3.9K
3.9K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R879
R880
R881
R894
R895
1-216-828-11
1-216-833-11
1-216-833-11
1-216-821-11
1-216-833-11
METAL CHIP
RES, CHIP
RES, CHIP
METAL CHIP
RES, CHIP
3.9K
10K
10K
1K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R899
1-216-864-11 METAL CHIP
0
5%
1/16W
Description
Remark
FB811
FB812
1-414-760-21 FERRITE BEAD INDUCTOR CHIP
1-500-329-21 FERRITE BEAD INDUCTOR CHIP
FB813
FB814
FB815
FB818
FB819
1-500-329-21
1-414-760-21
1-414-235-22
1-414-760-21
1-414-760-21
Ref. No.
FERRITE BEAD INDUCTOR CHIP
FERRITE BEAD INDUCTOR CHIP
FERRITE BEAD INDUCTOR CHIP
FERRITE BEAD INDUCTOR CHIP
FERRITE BEAD INDUCTOR CHIP
IC801
IC802
IC803
IC805
IC806
8-759-710-88
8-759-431-14
8-759-524-05
8-752-402-48
8-759-058-58
NJM431U-TE2
PQ3DZ53U
TC74VHC126FT (EL)
CXD2726Q-4
TC7S04FU (TE85R)
IC807
IC808
IC809
8-759-711-82 IC NJM4580E (T1)
8-759-711-82 IC NJM4580E (T1)
8-759-711-82 IC NJM4580E (T1)
< COIL >
L801
L802
1-412-058-11 INDUCTOR CHIP 10uH
1-412-060-11 INDUCTOR CHIP 22uH
< TRANSISTOR >
Q801
Remark
8-729-920-85 TRANSISTOR 2SD1664-T101-QR
< RESISTOR >
R801
R802
R803
R804
R805
1-216-864-11
1-216-308-00
1-216-809-11
1-219-274-11
1-216-813-11
METAL CHIP
METAL CHIP
METAL CHIP
RES, CHIP
METAL CHIP
0
4.7
100
220
220
5%
5%
5%
2%
5%
1/16W
1/10W
1/16W
1/16W
1/16W
R806
R807
R811
R812
R813
1-219-286-11
1-216-864-11
1-216-861-11
1-216-859-11
1-216-864-11
RES, CHIP
METAL CHIP
METAL CHIP
RES, CHIP
METAL CHIP
680
0
2.2M
1.5M
0
2%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R815
R816
R817
R818
R819
1-216-845-11
1-216-821-11
1-216-821-11
1-216-821-11
1-216-864-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
1K
1K
1K
0
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R820
R822
R823
R824
R825
1-216-821-11
1-216-809-11
1-216-821-11
1-216-845-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
100
1K
100K
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R826
R827
R828
R829
R830
1-216-864-11
1-216-809-11
1-216-805-11
1-216-805-11
1-216-864-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
100
47
47
0
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R832
R833
R834
R835
R837
1-216-821-11
1-216-809-11
1-216-839-11
1-216-843-11
1-216-831-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
100
33K
68K
6.8K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R838
1-216-841-11 METAL CHIP
47K
5%
1/16W
< VIBRATOR >
64
X801
1-767-467-11 VIBRATOR, CRYSTAL (16.9344MHz)
**************************************************************
KEY BOARD
**********
1-694-660-11
3-040-992-02
3-040-993-01
3-040-997-01
3-041-371-02
*
*
*
*
CONDUCTIVE BOARD, CONNECTION
HOLDER (LCD)
PLATE (LCD), LIGHT GUIDE
PLATE (LCD), GROUND
SHEET (REFLECTOR)
< CAPACITOR >
C951
C952
C953
C956
1-164-004-11
1-163-037-11
1-163-137-00
1-164-489-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.022uF
680PF
0.22uF
10%
10%
5%
10%
25V
25V
50V
16V
KEY
Ref. No.
Part No.
Description
Remark
C960
1-163-037-11 CERAMIC CHIP
0.022uF
10%
25V
C961
C962
C963
1-164-004-11 CERAMIC CHIP
1-164-004-11 CERAMIC CHIP
1-164-004-11 CERAMIC CHIP
0.1uF
0.1uF
0.1uF
10%
10%
10%
25V
25V
25V
< CONNECTOR >
CN901
1-794-065-21 PLUG, CONNECTOR 14P
Ref. No.
Part No.
Description
Remark
LSW903 1-771-476-11 SWITCH, KEY BOARD (WITH LED)
(SOUND EQ) (C8500X)
LSW904 1-762-620-21 SWITCH, KEY BOARD (WITH LED) (MENU)
(C8500R)
LSW904 1-771-476-11 SWITCH, KEY BOARD (WITH LED) (MENU)
(C8500X)
LSW905 1-762-620-21 SWITCH, KEY BOARD (WITH LED)
(PTY, DSPL) (C8500R)
LSW905 1-771-476-11 SWITCH, KEY BOARD (WITH LED) (DSPL)
(C8500X)
< DIODE >
D901
D902
D903
D904
D951
8-719-423-32
8-719-422-64
8-719-422-64
8-719-422-64
8-719-420-90
DIODE
DIODE
DIODE
DIODE
DIODE
MA8120-M-TX
MA8062-M-TX
MA8062-M-TX
MA8062-M-TX
MA8051-M-TX
D952
D954
8-719-422-64 DIODE MA8062-M-TX
8-719-422-89 DIODE MA8082-H-TX
LSW906 1-762-620-21 SWITCH, KEY BOARD (WITH LED) (LIST)
(C8500R)
LSW906 1-771-476-11 SWITCH, KEY BOARD (WITH LED) (LIST)
(C8500X)
LSW907 1-762-620-21 SWITCH, KEY BOARD (WITH LED) (ENTER)
(C8500R)
LSW907 1-771-476-11 SWITCH, KEY BOARD (WITH LED) (ENTER)
(C8500X)
LSW908 1-771-610-11 SWITCH, TACTILE (WITH LED) (MODE)
(C8500R)
< IC >
IC901
IC951
8-759-653-26 IC LC75878W
8-749-012-25 IC RS-170-TU
< LIQUID CRYSTAL DISPLAY >
LCD901 1-803-915-11 DISPLAY PANEL, LIQUID CRYSTAL (C8500R)
LCD901 1-803-915-21 DISPLAY PANEL, LIQUID CRYSTAL (C8500X)
< LED >
LED901 8-719-026-38 LED CL-150SR-CD-T (ILLUMINATION)
(C8500X)
LED901 8-719-064-68 LED LBT676-J2/K1/K2 (ILLUMINATION)
(C8500R)
LED902 8-719-026-38 LED CL-150SR-CD-T (ILLUMINATION)
(C8500X)
LED902 8-719-064-68 LED LBT676-J2/K1/K2 (ILLUMINATION)
(C8500R)
LED903 8-719-026-38 LED CL-150SR-CD-T (ILLUMINATION)
(C8500X)
LED903 8-719-064-68 LED LBT676-J2/K1/K2 (ILLUMINATION)
(C8500R)
LED904 8-719-026-38 LED CL-150SR-CD-T (ILLUMINATION)
(C8500X)
LED904 8-719-064-68 LED LBT676-J2/K1/K2 (ILLUMINATION)
(C8500R)
LED910 8-719-078-19 LED LWA673-R1S2*1 (LCD BACK LIGHT)
LED911 8-719-078-19 LED LWA673-R1S2*1 (LCD BACK LIGHT)
LED912
LED913
LED914
LED915
8-719-078-19
8-719-078-19
8-719-078-19
8-719-078-19
LED
LED
LED
LED
LWA673-R1S2*1 (LCD BACK LIGHT)
LWA673-R1S2*1 (LCD BACK LIGHT)
LWA673-R1S2*1 (LCD BACK LIGHT)
LWA673-R1S2*1 (LCD BACK LIGHT)
< SWITCH >
LSW901 1-771-610-11 SWITCH, TACTILE (WITH LED) (OFF) (C8500R)
LSW901 1-771-883-11 SWITCH, TACTILE (WITH LED) (OFF) (C8500X)
LSW902 1-762-620-21 SWITCH, KEY BOARD (WITH LED) (SOURCE)
(C8500R)
LSW902 1-771-476-11 SWITCH, KEY BOARD (WITH LED) (SOURCE)
(C8500X)
LSW903 1-762-620-21 SWITCH, KEY BOARD (WITH LED)
(SOUND EQ) (C8500R)
LSW908 1-771-883-11 SWITCH, TACTILE (WITH LED (MODE)
(C8500X)
LSW909 1-762-737-11 SWITCH, KEYBOARD (LED) (DSO)
LSW910 1-762-620-21 SWITCH, KEY BOARD (WITH LED) (TA)
(C8500R)
LSW911 1-762-620-21 SWITCH, KEY BOARD (WITH LED) (AF)
(C8500R)
LSW912 1-771-610-11 SWITCH, TACTILE (WITH LED) (6) (C8500R)
LSW912
LSW913
LSW913
LSW914
LSW914
1-771-883-11
1-771-610-11
1-771-883-11
1-771-610-11
1-771-883-11
SWITCH, TACTILE (WITH LED) (6) (C8500X)
SWITCH, TACTILE (WITH LED) (5) (C8500R)
SWITCH, TACTILE (WITH LED) (5) (C8500X)
SWITCH, TACTILE (WITH LED) (4) (C8500R)
SWITCH, TACTILE (WITH LED) (4) (C8500X)
LSW915 1-771-610-11 SWITCH, TACTILE (WITH LED) (3) (C8500R)
LSW915 1-771-883-11 SWITCH, TACTILE (WITH LED) (3) (C8500X)
LSW916 1-771-610-11 SWITCH, TACTILE (WITH LED) (SHUF 2)
(C8500R)
LSW916 1-771-883-11 SWITCH, TACTILE (WITH LED) (SHUF 2)
(C8500X)
LSW917 1-771-610-11 SWITCH, TACTILE (WITH LED) (REP 1)
(C8500R)
LSW917 1-771-883-11 SWITCH, TACTILE (WITH LED) (REP 1)
(C8500X)
< TRANSISTOR >
Q901
Q902
Q903
8-729-904-75 TRANSISTOR DTD114EK-T-146 (C8500R)
8-729-904-75 TRANSISTOR DTD114EK-T-146 (C8500R)
8-729-904-75 TRANSISTOR DTD114EK-T-146
< RESISTOR >
R901
R902
R903
R904
R905
1-216-647-11
1-216-647-11
1-216-647-11
1-216-651-11
1-216-655-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
680
680
680
1K
1.5K
0.5%
0.5%
0.5%
0.5%
0.5%
1/10W
1/10W
1/10W
1/10W
1/10W
R906
R907
R908
R909
R910
1-216-655-11
1-216-659-11
1-216-663-11
1-216-667-11
1-216-671-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1.5K
2.2K
3.3K
4.7K
6.8K
0.5%
0.5%
0.5%
0.5%
0.5%
1/10W
1/10W
1/10W
1/10W
1/10W
65
KEY
Ref. No.
MAIN
Part No.
Description
R911
R912
R913
R914
R915
1-208-806-11
1-216-647-11
1-216-647-11
1-216-647-11
1-216-651-11
RES, CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
680
680
680
1K
2%
0.5%
0.5%
0.5%
0.5%
1/10W
1/10W
1/10W
1/10W
1/10W
R916
R917
R918
R919
R920
1-216-655-11
1-216-655-11
1-216-659-11
1-216-663-11
1-216-667-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1.5K
1.5K
2.2K
3.3K
4.7K
0.5%
0.5%
0.5%
0.5%
0.5%
1/10W
1/10W
1/10W
1/10W
1/10W
R921
1-216-810-11 METAL CHIP
120
5%
R921
1-216-811-11 METAL CHIP
150
5%
R922
1-216-807-11 METAL CHIP
68
5%
R923
1-216-811-11 METAL CHIP
150
5%
R923
1-216-812-11 METAL CHIP
180
5%
R924
1-216-807-11 METAL CHIP
68
5%
R925
1-216-811-11 METAL CHIP
150
5%
R925
1-216-812-11 METAL CHIP
180
5%
R926
1-216-807-11 METAL CHIP
68
5%
R927
1-216-029-00 METAL CHIP
150
5%
R927
1-216-037-00 METAL CHIP
330
5%
R928
1-216-021-00 METAL CHIP
68
5%
R929
1-216-033-00 METAL CHIP
220
5%
R931
R932
1-216-813-11 METAL CHIP
1-216-813-11 METAL CHIP
220
220
5%
5%
R933
1-216-813-11 METAL CHIP
220
5%
R934
1-216-813-11 METAL CHIP
220
5%
R938
R939
1-216-809-11 METAL CHIP
1-216-813-11 METAL CHIP
100
220
5%
5%
R940
1-216-821-11 METAL CHIP
1K
5%
R951
R952
R953
R954
R955
1-216-819-11
1-216-807-11
1-216-857-11
1-216-821-11
1-216-049-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
RES, CHIP
680
68
1M
1K
1K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/10W
R956
R957
R958
R960
R961
1-216-049-11
1-216-841-11
1-216-037-00
1-216-041-00
1-216-829-11
RES, CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
47K
330
470
4.7K
5%
5%
5%
5%
5%
1/10W
1/16W
1/10W
1/10W
1/16W
R962
R963
R964
R970
1-216-829-11
1-216-829-11
1-216-829-11
1-216-815-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
4.7K
4.7K
330
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
66
Remark
1/16W
(C8500X)
1/16W
(C8500R)
1/16W
(C8500R)
1/16W
(C8500R)
1/16W
(C8500X)
1/16W
(C8500R)
1/16W
(C8500R)
1/16W
(C8500X)
1/16W
(C8500R)
1/10W
(C8500R)
1/10W
(C8500X)
1/10W
(C8500R)
1/10W
(C8500X)
1/16W
1/16W
1/16W
(C8500R)
1/16W
(C8500R)
1/16W
1/16W
(C8500X)
1/16W
(C8500X)
Ref. No.
Part No.
Description
Remark
R971
1-216-815-11 METAL CHIP
330
5%
1/16W
R972
R973
R975
R976
R977
1-216-041-00
1-216-815-11
1-216-864-11
1-216-815-11
1-216-815-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
470
330
0
330
330
5%
5%
5%
5%
5%
1/10W
1/16W
1/16W
1/16W
1/16W
R978
R999
1-216-815-11 METAL CHIP
1-216-864-11 METAL CHIP
330
0
5%
5%
1/16W
1/16W
(C8500X)
< ROTARY ENCODER >
RE901
1-475-014-11 ENCODER, ROTARY (VOLUME/BASS/TREBLE/
BALANCE/FADER CONTROL)
< SWITCH >
S901
1-771-884-11 SWITCH, TACTILE (WITH LED)
(SEEK/AMS - . m)
S902
1-771-884-11 SWITCH, TACTILE (WITH LED)
(DISC +, PRST +)
S903
1-771-884-11 SWITCH, TACTILE (WITH LED)
(SEEK/AMS + > M)
S904
1-771-884-11 SWITCH, TACTILE (WITH LED)
(DISC -, PRST -)
**************************************************************
*
*
*
*
A-3294-906-A
A-3294-915-A
A-3294-918-A
A-3294-919-A
MAIN BOARD, COMPLETE (C8500X)
MAIN BOARD, COMPLETE (C8500R: TYPE A)
MAIN BOARD, COMPLETE (C8500R: TYPE B)
MAIN BOARD, COMPLETE (C8500R: TYPE C)
*********************
*
*
*
*
3-040-996-01
3-040-998-01
3-041-261-01
3-045-994-01
7-685-793-09
HEAT SINK (2P)
BRACKET (IC)
BRACKET (TR)
COVER (DSP), SHIELD
SCREW +PTT 2.6X8 (S)
7-685-795-09 SCREW +PTT 2.6X12 (S)
< BUZZER >
BZ101
1-504-920-11 BUZZER
< CAPACITOR >
C101
C103
C104
C105
C106
1-107-826-11
1-107-725-11
1-162-923-11
1-131-661-21
1-126-176-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
ELECT
0.1uF
0.1uF
47PF
100uF
220uF
10%
10%
5%
20%
20%
16V
16V
50V
10V
10V
C107
C108
C109
C110
C111
1-107-826-11
1-107-826-11
1-162-970-11
1-117-681-11
1-163-021-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.01uF
100uF
0.01uF
10%
10%
10%
20%
10%
16V
16V
25V
16V
50V
C112
C113
C114
C115
C116
1-164-816-11
1-117-681-11
1-124-584-00
1-163-031-11
1-162-970-11
CERAMIC CHIP
ELECT CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
220PF
100uF
100uF
0.01uF
0.01uF
2%
20%
20%
10%
50V
16V
10V
50V
25V
C117
C118
1-124-584-00 ELECT
1-126-926-11 ELECT
100uF
1000uF
20%
20%
10V
10V
MAIN
Ref. No.
Part No.
Description
Remark
C119
C120
C121
1-125-701-11 DOUBLE LAYER
1-164-360-11 CERAMIC CHIP
1-104-942-11 ELECT
0.047F
0.1uF
1uF
C122
C123
C124
C126
C127
1-164-156-11
1-164-360-11
1-164-156-11
1-163-009-11
1-163-009-11
0.1uF
0.1uF
0.1uF
0.001uF
0.001uF
C129
C130
C201
1-163-038-00 CERAMIC CHIP
1-163-038-00 CERAMIC CHIP
1-164-156-11 CERAMIC CHIP
0.1uF
0.1uF
0.1uF
C202
1-162-962-11 CERAMIC CHIP
470PF
10%
C203
1-164-739-11 CERAMIC CHIP
560PF
5%
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
20%
5.5V
16V
50V
10%
10%
25V
16V
25V
50V
50V
C204
1-164-505-11 CERAMIC CHIP
2.2uF
C205
1-162-920-11 CERAMIC CHIP
27PF
5%
C206
1-162-920-11 CERAMIC CHIP
27PF
5%
C207
1-164-156-11 CERAMIC CHIP
0.1uF
C208
1-164-156-11 CERAMIC CHIP
0.1uF
C209
1-163-263-11 CERAMIC CHIP
330PF
C210
1-162-966-11 CERAMIC CHIP
0.0022uF 10%
C211
1-162-927-11 CERAMIC CHIP
100PF
5%
C214
C215
1-162-970-11 CERAMIC CHIP
1-163-021-11 CERAMIC CHIP
0.01uF
0.01uF
10%
10%
C219
C220
C221
1-163-231-11 CERAMIC CHIP
1-126-157-11 ELECT
1-124-589-11 ELECT
15PF
10uF
47uF
5%
20%
20%
C223
C224
1-164-227-11 CERAMIC CHIP
1-126-157-11 ELECT
0.022uF
10uF
10%
20%
C226
C227
C229
C230
C231
1-124-589-11
1-127-573-11
1-164-156-11
1-124-589-11
1-107-826-11
47uF
1uF
0.1uF
47uF
0.1uF
20%
10%
C232
1-162-964-11 CERAMIC CHIP
0.001uF
10%
C233
1-163-038-00 CERAMIC CHIP
0.1uF
C234
C235
1-164-489-11 CERAMIC CHIP
1-162-964-11 CERAMIC CHIP
0.22uF
0.001uF
C236
1-163-038-00 CERAMIC CHIP
0.1uF
C237
C238
1-126-157-11 ELECT
1-162-964-11 CERAMIC CHIP
10uF
0.001uF
C239
1-162-915-11 CERAMIC CHIP
10PF
C240
1-164-005-11 CERAMIC CHIP
0.47uF
ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
5%
20%
10%
10%
10%
20%
10%
25V
25V
25V
(C8500R)
50V
(C8500R)
50V
(C8500R)
16V
(C8500R)
50V
(C8500R)
50V
(C8500R)
25V
(C8500R)
25V
(C8500R)
50V
(C8500R)
50V
(C8500R)
50V
(C8500R)
25V
50V
50V
16V
16V
(C8500R)
25V
16V
16V
16V
25V
16V
16V
50V
(C8500R)
25V
(C8500R)
16V
50V
(C8500R)
25V
(C8500R)
16V
50V
(C8500R)
0.5PF 50V
(C8500R)
25V
(C8500R)
Ref. No.
Part No.
Description
Remark
C241
1-164-315-11 CERAMIC CHIP
470PF
5%
50V
(C8500R)
C242
1-163-809-11 CERAMIC CHIP
0.047uF
10%
C245
1-107-725-11 CERAMIC CHIP
0.1uF
10%
C246
C301
C302
1-163-038-00 CERAMIC CHIP
1-164-346-11 CERAMIC CHIP
1-127-573-11 CERAMIC CHIP
0.1uF
1uF
1uF
10%
25V
(C8500R)
16V
(C8500R)
25V
16V
16V
C303
C304
C305
C306
C307
1-162-964-11
1-127-573-11
1-164-227-11
1-162-968-11
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.001uF
1uF
0.022uF
0.0047uF
0.01uF
10%
10%
10%
10%
10%
50V
16V
25V
50V
25V
C308
C309
C311
C312
C314
1-107-823-11
1-164-346-11
1-125-838-11
1-107-725-11
1-125-838-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.47uF
1uF
2.2uF
0.1uF
2.2uF
10%
10%
10%
10%
16V
16V
6.3V
16V
6.3V
C315
C316
C317
C318
C319
1-124-589-11
1-127-573-11
1-127-573-11
1-127-573-11
1-127-573-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
47uF
1uF
1uF
1uF
1uF
20%
10%
10%
10%
10%
16V
16V
16V
16V
16V
C320
C321
1-127-573-11 CERAMIC CHIP
1-127-573-11 CERAMIC CHIP
1uF
1uF
10%
10%
C322
1-127-573-11 CERAMIC CHIP
1uF
10%
C323
1-127-573-11 CERAMIC CHIP
1uF
10%
C324
1-127-573-11 CERAMIC CHIP
1uF
10%
C325
1-127-573-11 CERAMIC CHIP
1uF
10%
C326
1-127-573-11 CERAMIC CHIP
1uF
10%
C327
1-124-589-11 ELECT
47uF
20%
C328
1-124-589-11 ELECT
47uF
20%
C329
1-124-589-11 ELECT
47uF
20%
C330
1-124-584-00 ELECT
100uF
20%
C331
1-124-584-00 ELECT
100uF
20%
C332
1-124-584-00 ELECT
100uF
20%
C333
1-124-584-00 ELECT
100uF
20%
C334
1-124-584-00 ELECT
100uF
20%
C335
1-124-584-00 ELECT
100uF
20%
C336
C337
1-107-725-11 CERAMIC CHIP
1-163-235-11 CERAMIC CHIP
0.1uF
22PF
10%
5%
C338
1-163-235-11 CERAMIC CHIP
22PF
5%
16V
16V
(C8500X)
16V
(C8500X)
16V
(C8500X)
16V
(C8500X)
16V
(C8500X)
16V
(C8500X)
16V
(C8500X)
16V
(C8500X)
16V
(C8500X)
10V
(C8500X)
10V
(C8500X)
10V
(C8500X)
10V
(C8500X)
10V
(C8500X)
10V
(C8500X)
16V
50V
(C8500X)
50V
(C8500X)
67
MAIN
Ref. No.
Part No.
Description
Remark
Ref. No.
Part No.
Description
Remark
C339
1-163-235-11 CERAMIC CHIP
22PF
5%
50V
(C8500X)
C381
C382
1-163-038-00 CERAMIC CHIP
1-163-038-00 CERAMIC CHIP
0.1uF
0.1uF
25V
25V
C340
1-163-235-11 CERAMIC CHIP
22PF
5%
C341
1-163-235-11 CERAMIC CHIP
22PF
5%
C342
1-163-235-11 CERAMIC CHIP
22PF
5%
C383
C384
C385
C386
C387
1-163-038-00
1-163-031-11
1-163-031-11
1-163-031-11
1-163-031-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.01uF
0.01uF
0.01uF
0.01uF
25V
50V
50V
50V
50V
C343
C344
1-126-157-11 ELECT
1-126-157-11 ELECT
10uF
10uF
20%
20%
50V
(C8500X)
50V
(C8500X)
50V
(C8500X)
16V
16V
C345
C346
C347
C348
C349
1-126-157-11
1-126-157-11
1-164-506-11
1-164-506-11
1-164-489-11
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
10uF
10uF
4.7uF
4.7uF
0.22uF
20%
20%
C399
C401
C402
C403
C405
1-163-251-11
1-164-360-11
1-124-589-11
1-127-573-11
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
100PF
0.1uF
47uF
1uF
0.01uF
10%
C350
C351
C352
C353
1-164-489-11
1-164-489-11
1-164-489-11
1-127-573-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.22uF
0.22uF
0.22uF
1uF
10%
10%
10%
10%
C406
C407
C408
C409
C410
1-131-661-21
1-163-038-00
1-128-057-11
1-128-057-11
1-135-474-21
ELECT CHIP
CERAMIC CHIP
ELECT
ELECT
ELECT
100uF
0.1uF
330uF
330uF
330uF
C501
C502
1-164-360-11 CERAMIC CHIP
1-163-017-00 CERAMIC CHIP
0.1uF
0.0047uF 5%
C354
1-124-259-11 ELECT
4.7uF
20%
C502
1-104-760-11 CERAMIC CHIP
0.047uF
C504
C505
1-163-038-00 CERAMIC CHIP
1-163-038-00 CERAMIC CHIP
0.1uF
0.1uF
C506
C507
C508
C509
C510
1-164-360-11
1-164-315-11
1-164-816-11
1-163-234-11
1-163-237-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
470PF
220PF
20PF
27PF
C511
C512
C513
C514
C515
1-162-964-11
1-107-725-11
1-163-038-00
1-163-237-11
1-163-237-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.001uF
0.1uF
0.1uF
27PF
27PF
C516
C517
C518
C519
1-164-156-11
1-107-823-11
1-107-725-11
1-163-038-00
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.47uF
0.1uF
0.1uF
C601
C602
C603
C604
C605
1-163-038-00
1-124-229-00
1-163-021-11
1-107-725-11
1-163-021-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
33uF
0.01uF
0.1uF
0.01uF
C606
C607
C701
C702
C703
1-162-970-11
1-163-009-11
1-162-970-11
1-104-942-11
1-163-038-00
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
0.01uF
0.001uF
0.01uF
1uF
0.1uF
C704
C705
C706
C707
C709
1-163-038-00
1-163-038-00
1-107-826-11
1-162-974-11
1-126-154-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
0.1uF
0.1uF
0.1uF
0.01uF
47uF
20%
25V
25V
16V
50V
6.3V
C710
C711
1-163-038-00 CERAMIC CHIP
1-107-725-11 CERAMIC CHIP
0.1uF
0.1uF
10%
25V
16V
16V
16V
16V
16V
16V
16V
16V
16V
16V
(C8500X)
16V
(C8500R)
C354
1-104-942-11 ELECT
1uF
20%
50V
(C8500X)
50V
50V
50V
50V
C355
C356
C357
C358
1-162-919-11
1-162-919-11
1-162-919-11
1-162-919-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
22PF
22PF
22PF
22PF
5%
5%
5%
5%
C359
C360
C361
C362
1-163-235-11
1-162-919-11
1-163-038-00
1-124-261-00
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
22PF
22PF
0.1uF
10uF
5%
5%
20%
C362
1-124-589-11 ELECT
47uF
20%
C363
C364
C365
C366
C367
1-163-009-11
1-163-009-11
1-107-725-11
1-162-927-11
1-162-964-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.001uF
0.001uF
0.1uF
100PF
0.001uF
10%
10%
10%
5%
10%
C368
C369
C370
C371
C372
C373
1-104-942-11
1-162-964-11
1-104-942-11
1-135-473-21
1-107-725-11
1-107-826-11
ELECT
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
1uF
0.001uF
1uF
3300uF
0.1uF
0.1uF
20%
10%
20%
20%
10%
10%
50V
50V
50V
16V
16V
16V
(C8500X)
C374
1-107-826-11 CERAMIC CHIP
0.1uF
10%
C375
1-107-826-11 CERAMIC CHIP
0.1uF
10%
C376
1-107-826-11 CERAMIC CHIP
0.1uF
10%
C377
1-107-826-11 CERAMIC CHIP
0.1uF
10%
C378
1-107-826-11 CERAMIC CHIP
0.1uF
10%
16V
(C8500X)
16V
(C8500X)
16V
(C8500X)
16V
(C8500X)
16V
(C8500X)
C379
C380
1-127-573-11 CERAMIC CHIP
1-127-573-11 CERAMIC CHIP
1uF
1uF
10%
10%
50V
50V
25V
50V
(C8500R)
16V
(C8500X)
50V
50V
16V
50V
50V
C519
68
16V
16V
(C8500X)
5%
20%
10%
10%
20%
20%
20%
20%
10%
5%
2%
5%
5%
10%
10%
5%
5%
50V
16V
16V
16V
25V
10V
25V
6.3V
6.3V
6.3V
16V
50V
(C8500R)
50V
(C8500X)
25V
25V
16V
50V
50V
50V
50V
50V
16V
25V
50V
50V
25V
16V
16V
25V
(C8500R: TYPE A)
1-164-156-11 CERAMIC CHIP 0.1uF
25V
(C8500X, C8500R: TYPE B/C)
10%
10%
20%
10%
10%
10%
10%
10%
10%
20%
10%
25V
10V
50V
16V
50V
25V
50V
25V
50V
25V
MAIN
Ref. No.
Part No.
Description
Remark
C712
C713
C714
1-163-038-00 CERAMIC CHIP
1-163-038-00 CERAMIC CHIP
1-162-970-11 CERAMIC CHIP
0.1uF
0.1uF
0.01uF
10%
25V
25V
25V
C715
C751
C752
C753
C754
1-162-970-11
1-162-970-11
1-162-970-11
1-162-927-11
1-162-927-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.01uF
0.01uF
100PF
100PF
10%
10%
10%
5%
5%
25V
25V
25V
50V
50V
C755
C756
C757
C759
1-162-927-11
1-162-927-11
1-162-927-11
1-162-927-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100PF
100PF
100PF
100PF
5%
5%
5%
5%
50V
50V
50V
50V
< CONNECTOR >
CN101
CN102
* CN301
CN302
1-774-701-11
1-764-808-21
1-564-506-11
1-774-700-11
CN401
PIN, CONNECTOR 16P
JACK (ANT) (FM/AM ANTENNA)
PLUG, CONNECTOR 3P
JACK, PIN 6P (BUS CONTROL IN,
AUDIO OUT REAR/FRONT)
1-764-617-12 PIN, CONNECTOR (PC BOARD) 30P
CN601
CN701
1-580-907-31 PLUG, CONNECTOR (BUS CONTROL IN)
1-770-408-11 CONNECTOR, BOARD TO BOARD 14P
< DIODE >
D101
D102
D103
D104
D105
8-719-420-51
8-719-422-29
8-719-060-81
8-719-801-78
8-719-420-14
DIODE
DIODE
DIODE
DIODE
DIODE
MA729-TX
MA8047-L-TX
MA735-TX
MA152WK-TX
MA8082-M
D106
D107
D108
D109
D201
8-719-060-81
8-719-422-62
8-719-422-86
8-719-977-12
8-719-422-41
DIODE
DIODE
DIODE
DIODE
DIODE
MA735-TX
MA8062-L-TX
MA8082-L-TX
MA8068-M-TX
MA8051-L-TX
D202
D203
D204
D205
D301
8-719-422-16
8-719-800-76
8-719-420-90
8-719-073-01
8-719-422-64
DIODE
DIODE
DIODE
DIODE
DIODE
MA8039-L-TX
MA153-TX (C8500R)
MA8051-M-TX (C8500R)
MA111-TX
MA8062-M-TX
D302
D352
D353
D354
D355
8-719-073-01
8-719-420-14
8-719-801-78
8-719-801-78
8-719-079-66
DIODE
DIODE
DIODE
DIODE
DIODE
MA111-TX
MA8082-M (TX)
MA152WK-TX
MA152WK-TX
1ZB22 (TPB5.SONY) (C8500R)
D355
D356
D356
D357
D357
8-719-200-82
8-719-079-66
8-719-200-82
8-719-079-66
8-719-200-82
DIODE
DIODE
DIODE
DIODE
DIODE
11ES2-TB5 (C8500X)
1ZB22 (TPB5.SONY) (C8500R)
11ES2-TB5 (C8500X)
1ZB22 (TPB5.SONY) (C8500R)
11ES2-TB5 (C8500X)
D358
D358
D359
D359
D360
8-719-079-66
8-719-200-82
8-719-079-66
8-719-200-82
8-719-079-66
DIODE
DIODE
DIODE
DIODE
DIODE
1ZB22 (TPB5.SONY) (C8500R)
11ES2-TB5 (C8500X)
1ZB22 (TPB5.SONY) (C8500R)
11ES2-TB5 (C8500X)
1ZB22 (TPB5.SONY) (C8500R)
D360
D361
D361
D362
8-719-200-82
8-719-079-66
8-719-200-82
8-719-079-66
DIODE
DIODE
DIODE
DIODE
11ES2-TB5 (C8500X)
1ZB22 (TPB5.SONY) (C8500R)
11ES2-TB5 (C8500X)
1ZB22 (TPB5.SONY) (C8500R)
Ref. No.
Part No.
Description
D362
8-719-200-82 DIODE 11ES2-TB5 (C8500X)
D363
D501
D502
D601
D602
8-719-049-38
8-719-420-90
8-719-073-01
8-719-073-01
8-719-073-01
DIODE
DIODE
DIODE
DIODE
DIODE
1N5404TU
MA8051-M-TX (C8500R)
MA111-TX
MA111-TX
MA111-TX
D603
D604
D605
D606
D607
8-719-057-80
8-719-057-80
8-719-073-01
8-719-057-80
8-719-977-12
DIODE
DIODE
DIODE
DIODE
DIODE
MA8180-M-TX
MA8180-M-TX
MA111-TX
MA8180-M-TX
MA8068-M-TX
D608
D609
D610
D611
D612
8-719-420-51
8-719-057-80
8-719-073-01
8-719-073-01
8-719-977-12
DIODE
DIODE
DIODE
DIODE
DIODE
MA729-TX
MA8180-M-TX
MA111-TX
MA111-TX
MA8068-M-TX
D613
D614
D701
D702
D703
8-719-977-12
8-719-073-01
8-719-400-20
8-719-073-01
8-719-801-78
DIODE
DIODE
DIODE
DIODE
DIODE
MA8068-M-TX
MA111-TX
MA152WA-TX
MA111-TX
MA152WK-TX
D751
D752
D753
D754
D755
8-719-423-32
8-719-422-64
8-719-422-64
8-719-423-32
8-719-423-32
DIODE
DIODE
DIODE
DIODE
DIODE
MA8102-M
MA8062-M-TX
MA8062-M-TX
MA8102-M
MA8102-M
D756
D757
D758
D759
D760
8-719-422-64
8-719-422-64
8-719-423-32
8-719-422-64
8-719-422-64
DIODE
DIODE
DIODE
DIODE
DIODE
MA8062-M-TX
MA8062-M-TX
MA8120-M-TX
MA8062-M-TX
MA8062-M-TX
D761
D762
8-719-423-32 DIODE MA8102-M
8-719-422-64 DIODE MA8062-M-TX
Remark
< FUSE >
F1
1-532-877-11 FUSE (BLADE TYPE) (AUTO FUSE) 10A
< FERRITE BEAD >
FB201
1-500-245-11 FERRITE BEAD INDUCTOR CHIP (C8500R)
< IC >
IC201
IC202
IC301
IC302
IC303
8-759-650-68
8-759-711-82
8-759-653-27
8-759-521-35
8-759-593-97
IC
IC
IC
IC
IC
SAA6588T/V2-118 (C8500R)
NJM4580E (T1) (C8500R)
TDA7402TR
TL5001CD
NJM2160AM-TE2 (C8500X)
IC304
IC305
IC351
IC351
IC502
8-759-593-97
8-759-593-97
8-759-660-96
8-759-663-88
8-759-670-66
IC
IC
IC
IC
IC
NJM2160AM-TE2 (C8500X)
NJM2160AM-TE2 (C8500X)
TDA7560 (C8500X)
TA8268H (C8500R)
MB90574BPMT-G-263-BND (C8500X)
IC502
IC503
IC504
IC601
IC701
8-759-670-67
8-759-581-75
8-759-495-76
8-759-449-89
8-759-670-68
IC
IC
IC
IC
IC
MB90574BPMT-G-264-BND (C8500R)
XC61AN4102MR
RN5VD33AA-TL
BA8270F-E2
HD6432355A10F (C8500X)
69
MAIN
Ref. No.
IC701
IC702
Part No.
Description
Remark
8-759-672-71 IC HD6432355A21F (C8500R)
8-759-277-63 IC TC7W14FU (TE12R)
< JACK >
J651
1-566-822-41 JACK (REMOTE IN)
< COIL >
L101
L102
L103
L104
L201
1-469-673-21
1-469-674-21
1-469-675-21
1-414-185-51
1-414-185-51
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
100uH
220uH
100uH
22uH
22uH
L301
L351
L402
L701
1-414-179-51
1-419-476-11
1-469-673-21
1-414-856-51
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
2.2uH
250uH
100uH
10uH
< TRANSISTOR >
Q101
Q102
Q103
Q104
Q105
8-729-421-19
8-729-120-28
8-729-026-49
8-729-822-84
8-729-822-84
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
UN2213-TX
2SC2412K-T-146-R
2SA1037AK-T146-R
2SB1202FAT-TL
2SB1202FAT-TL
Q106
Q107
Q108
Q109
Q110
8-729-120-28
8-729-822-84
8-729-120-28
8-729-120-28
8-729-040-17
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC2412K-T-146-R
2SB1202FAT-TL
2SC2412K-T-146-R
2SC2412K-T-146-R
2SD2164-K
Q111
Q112
Q113
Q201
Q202
8-729-120-28
8-729-120-28
8-729-120-28
8-729-920-85
8-729-920-21
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC2412K-T-146-R
2SC2412K-T-146-R
2SC2412K-T-146-R
2SD1664-T101-QR
DTC314TK-T-146
Q203
Q204
Q205
Q206
Q207
8-729-106-60
8-729-421-22
8-729-920-21
8-729-424-08
8-729-421-22
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SB1132-T101-QR
UN2211-TX
DTC314TK-T-146
UN2111-TX
UN2211-TX
Q208
Q209
Q351
Q352
Q353
8-729-421-22
8-729-120-28
8-729-421-22
8-729-120-28
8-729-424-59
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
UN2211-TX (C8500R)
2SC2412K-T-146-R
UN2211-TX
2SC2412K-T-146-R
UN2212-TX
Q354
Q355
Q356
Q357
Q358
8-729-424-18
8-729-424-59
8-729-021-95
8-729-021-95
8-729-021-95
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
UN2113
UN2212-TX
RN1441-A (TE85L)
RN1441-A (TE85L)
RN1441-A (TE85L)
Q359
Q360
Q361
Q363
Q364
8-729-021-95
8-729-021-95
8-729-021-95
8-729-421-22
8-729-421-22
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
RN1441-A (TE85L)
RN1441-A (TE85L)
RN1441-A (TE85L)
UN2211-TX
UN2211-TX
Q365
Q366
Q401
Q404
Q405
8-729-807-35
8-729-807-35
8-729-822-84
8-729-120-28
8-729-120-28
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SB1123-T-TD
2SB1123-T-TD
2SB1202FAT-TL
2SC2412K-T-146-R
2SC2412K-T-146-R
70
Ref. No.
Part No.
Description
Remark
Q406
Q407
Q601
Q602
Q603
8-729-822-84
8-729-421-22
8-729-120-28
8-729-120-28
8-729-424-18
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SB1202FAT-TL
UN2211-TX
2SC2412K-T-146-R
2SC2412K-T-146-R
UN2113-TX
Q604
Q605
Q701
Q702
Q703
8-729-421-22
8-729-424-18
8-729-424-08
8-729-424-08
8-729-120-28
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
UN2211-TX
UN2113
UN2111-TX
UN2111-TX
2SC2412K-T-146-R
Q704
Q705
8-729-822-84 TRANSISTOR 2SB1202FAT-TL
8-729-120-28 TRANSISTOR 2SC2412K-T-146-R
< RESISTOR >
R101
R102
R103
R104
R105
1-216-839-11
1-218-879-11
1-216-845-11
1-218-903-11
1-218-290-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
33K
22K
100K
220K
6.2K
5%
0.5%
5%
0.5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R106
R107
R108
R109
R110
1-216-829-11
1-216-839-11
1-216-849-11
1-216-841-11
1-216-057-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
33K
220K
47K
2.2K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/10W
R111
R112
R113
R114
R115
1-216-057-00
1-216-057-00
1-216-049-11
1-216-049-11
1-216-041-00
METAL CHIP
METAL CHIP
RES, CHIP
RES, CHIP
METAL CHIP
2.2K
2.2K
1K
1K
470
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R116
R117
R118
R119
R120
1-216-049-11
1-216-037-00
1-216-033-00
1-216-825-11
1-216-817-11
RES, CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
330
220
2.2K
470
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/16W
1/16W
R121
R122
R123
R124
R125
1-216-049-11
1-216-833-11
1-216-829-11
1-216-845-11
1-216-308-00
RES, CHIP
RES, CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
10K
4.7K
100K
4.7
5%
5%
5%
5%
5%
1/10W
1/16W
1/16W
1/16W
1/10W
R126
R127
R128
R129
R130
1-216-845-11
1-216-833-11
1-216-839-11
1-216-833-11
1-216-077-00
METAL CHIP
RES, CHIP
METAL CHIP
RES, CHIP
RES, CHIP
100K
10K
33K
10K
15K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/10W
R131
R132
R133
R134
R136
1-216-841-11
1-216-845-11
1-216-841-11
1-216-845-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
RES, CHIP
47K
100K
47K
100K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R137
R138
R139
R140
R141
1-216-833-11
1-216-295-00
1-216-001-00
1-216-041-00
1-216-049-11
RES, CHIP
SHORT
METAL CHIP
METAL CHIP
RES, CHIP
10K
0
10
470
1K
5%
1/16W
5%
5%
5%
1/10W
1/10W
1/10W
R142
R201
1-216-049-11 RES, CHIP
1-216-853-11 METAL CHIP
1K
470K
5%
5%
1/10W
1/16W
(C8500R)
MAIN
Ref. No.
Part No.
Description
Remark
R202
1-216-821-11 METAL CHIP
1K
5%
R203
1-216-832-11 METAL CHIP
8.2K
5%
R204
1-216-817-11 METAL CHIP
470
5%
R205
R206
1-216-825-11 METAL CHIP
1-216-001-00 METAL CHIP
2.2K
10
5%
5%
R207
R208
1-216-001-00 METAL CHIP
1-216-001-00 METAL CHIP
10
10
5%
5%
R209
1-216-025-00 RES, CHIP
100
5%
R210
R211
1-216-025-00 RES, CHIP
1-216-025-00 RES, CHIP
100
100
5%
5%
R212
1-216-025-00 RES, CHIP
100
5%
R213
R214
1-216-864-11 METAL CHIP
1-216-001-00 METAL CHIP
0
10
5%
5%
1/10W
1/10W
(C8500R)
1/10W
(C8500R)
1/16W
1/10W
R215
R216
R217
R218
R219
1-216-841-11
1-216-817-11
1-216-839-11
1-216-829-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
RES, CHIP
47K
470
33K
4.7K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R220
R221
1-216-819-11 METAL CHIP
1-216-073-00 METAL CHIP
680
10K
5%
5%
R222
1-216-825-11 METAL CHIP
2.2K
5%
R223
1-216-073-00 METAL CHIP
10K
5%
R224
1-216-829-11 METAL CHIP
4.7K
5%
1/16W
1/10W
(C8500R)
1/16W
(C8500R)
1/10W
(C8500R)
1/16W
(C8500R)
R225
R226
1-216-815-11 METAL CHIP
1-216-845-11 METAL CHIP
330
100K
5%
5%
R227
1-216-825-11 METAL CHIP
2.2K
5%
R228
1-216-809-11 METAL CHIP
100
5%
R229
1-216-797-11 METAL CHIP
10
5%
R230
1-216-121-00 RES, CHIP
1M
5%
R231
1-216-809-11 METAL CHIP
100
5%
R233
R234
R236
1-216-825-11 METAL CHIP
1-216-295-00 SHORT
1-216-295-00 SHORT
2.2K
0
0
5%
R237
R238
R301
1-216-295-00 SHORT
1-216-295-00 SHORT
1-216-864-11 METAL CHIP
0
0 (C8500R)
0
5%
R302
R305
1-216-025-00 RES, CHIP
1-216-809-11 METAL CHIP
100
100
5%
5%
R305
1-216-817-11 METAL CHIP
470
5%
R306
R307
1-216-841-11 METAL CHIP
1-216-809-11 METAL CHIP
47K
100
5%
5%
1/16W
(C8500R)
1/16W
(C8500R)
1/16W
(C8500R)
1/16W
1/10W
(C8500R)
1/10W
1/10W
(C8500R)
1/10W
1/16W
1/16W
(C8500R)
1/16W
(C8500R)
1/16W
(C8500R)
1/16W
1/10W
(C8500R)
1/16W
(C8500R)
1/16W
1/16W
(C8500X)
1/10W
1/16W
(C8500R)
1/16W
(C8500X)
1/16W
1/16W
(C8500R)
Ref. No.
Part No.
Description
Remark
R307
1-216-817-11 METAL CHIP
470
5%
R310
1-216-809-11 METAL CHIP
100
5%
1/16W
(C8500X)
1/16W
R311
R312
R313
R314
R315
1-216-057-00
1-216-073-00
1-216-809-11
1-216-057-00
1-216-073-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
10K
100
2.2K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/16W
1/10W
1/10W
R317
R318
1-216-057-00 METAL CHIP
1-216-081-00 METAL CHIP
2.2K
22K
5%
5%
R319
1-216-081-00 METAL CHIP
22K
5%
R320
1-216-081-00 METAL CHIP
22K
5%
R321
1-216-081-00 METAL CHIP
22K
5%
1/10W
1/10W
(C8500X)
1/10W
(C8500X)
1/10W
(C8500X)
1/10W
(C8500X)
R322
1-216-081-00 METAL CHIP
22K
5%
R323
1-216-081-00 METAL CHIP
22K
5%
R324
1-216-049-11 RES, CHIP
1K
5%
R325
1-216-085-00 METAL CHIP
33K
5%
R326
1-216-085-00 METAL CHIP
33K
5%
R327
1-216-085-00 METAL CHIP
33K
5%
R328
1-216-085-00 METAL CHIP
33K
5%
R329
1-216-085-00 METAL CHIP
33K
5%
R330
1-216-085-00 METAL CHIP
33K
5%
R331
1-216-295-00 SHORT
0 (C8500R)
R332
R333
R334
R335
R336
1-216-295-00
1-216-295-00
1-216-295-00
1-216-295-00
1-216-295-00
0 (C8500R)
0 (C8500R)
0 (C8500R)
0 (C8500R)
0 (C8500R)
R337
1-216-089-00 RES, CHIP
47K
5%
R338
R339
R340
R341
1-216-833-11
1-216-089-00
1-216-073-00
1-216-864-11
RES, CHIP
RES, CHIP
METAL CHIP
METAL CHIP
10K
47K
10K
0
5%
5%
5%
5%
1/10W
(C8500X)
1/16W
1/10W
1/10W
1/16W
R343
R344
R345
R346
R347
1-216-813-11
1-216-813-11
1-216-813-11
1-216-813-11
1-216-813-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
220
220
220
220
220
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R348
R349
1-216-813-11 METAL CHIP
1-216-821-11 METAL CHIP
220
1K
5%
5%
R349
1-216-864-11 METAL CHIP
0
5%
1/16W
1/16W
(C8500R)
1/16W
(C8500X)
R350
R350
1-216-295-00 SHORT
1-216-073-00 METAL CHIP
0 (C8500R)
10K
5%
SHORT
SHORT
SHORT
SHORT
SHORT
1/10W
(C8500X)
1/10W
(C8500X)
1/10W
1/10W
(C8500X)
1/10W
(C8500X)
1/10W
(C8500X)
1/10W
(C8500X)
1/10W
(C8500X)
1/10W
(C8500X)
1/10W
(C8500X)
71
MAIN
Ref. No.
Part No.
Description
R351
R352
R353
R354
R355
1-216-837-11
1-216-837-11
1-216-837-11
1-216-837-11
1-216-081-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
22K
22K
22K
22K
22K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/10W
Remark
R356
R357
R358
R359
R360
1-216-081-00
1-216-841-11
1-216-841-11
1-216-821-11
1-216-864-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
22K
47K
47K
1K
0
5%
5%
5%
5%
5%
R361
R363
R364
R365
R366
1-216-821-11
1-216-809-11
1-216-065-00
1-216-065-00
1-216-065-00
METAL CHIP
METAL CHIP
RES, CHIP
RES, CHIP
RES, CHIP
1K
100
4.7K
4.7K
4.7K
R367
R368
R369
R370
R371
1-216-065-00
1-216-222-00
1-216-065-00
1-216-065-00
1-216-833-11
RES, CHIP
RES, CHIP
RES, CHIP
RES, CHIP
RES, CHIP
R372
R373
R374
R375
R376
1-216-833-11
1-216-222-00
1-216-222-00
1-216-864-11
1-216-001-00
RES, CHIP
RES, CHIP
RES, CHIP
METAL CHIP
METAL CHIP
Part No.
Description
Remark
R390
1-216-864-11 METAL CHIP
0
5%
R391
1-216-073-00 METAL CHIP
10K
5%
R391
1-216-295-00 SHORT
0 (C8500X)
1/10W
1/16W
1/16W
1/16W
1/16W
R392
1-216-833-11 RES, CHIP
10K
5%
R392
1-216-864-11 METAL CHIP
0
5%
R393
1-216-833-11 RES, CHIP
10K
5%
5%
5%
5%
5%
5%
1/16W
1/16W
1/10W
1/10W
1/10W
R393
1-216-864-11 METAL CHIP
0
5%
R398
1-216-041-11 METAL CHIP
470
5%
4.7K
10K
4.7K
4.7K
10K
5%
5%
5%
5%
5%
1/10W
1/8W
1/10W
1/10W
1/16W
R408
R409
R412
R414
R415
1-216-822-11
1-216-073-00
1-216-829-11
1-216-049-11
1-216-049-11
METAL CHIP
METAL CHIP
METAL CHIP
RES, CHIP
RES, CHIP
1.2K
10K
4.7K
1K
1K
5%
5%
5%
5%
5%
1/16W
1/10W
1/16W
1/10W
1/10W
10K
10K
10K
0
10
5%
5%
5%
5%
5%
1/16W
1/8W
1/8W
1/16W
1/10W
(C8500X)
R416
R417
R418
R419
R420
1-216-065-00
1-216-049-11
1-216-041-00
1-216-820-11
1-216-864-11
RES, CHIP
RES, CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
1K
470
820
0
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/16W
1/16W
R421
R501
R502
1-216-864-11 METAL CHIP
1-216-081-00 METAL CHIP
1-216-841-11 METAL CHIP
0
22K
47K
R502
1-216-864-11 METAL CHIP
R503
1-216-845-11 METAL CHIP
R503
1-216-833-11 RES, CHIP
R504
R505
R506
R507
1-216-025-00
1-216-295-00
1-216-049-11
1-216-049-11
R508
R509
R510
1-216-049-11 RES, CHIP
1-216-049-11 RES, CHIP
1-216-097-00 RES, CHIP
1K
1K
100K
5%
5%
5%
R511
1-216-845-11 METAL CHIP
100K
5%
R512
1-216-821-11 METAL CHIP
1K
5%
R513
R514
1-216-049-11 RES, CHIP
1-216-049-11 RES, CHIP
1K
1K
5%
5%
R515
R516
R517
1-216-864-11 METAL CHIP
1-216-845-11 METAL CHIP
1-216-049-11 RES, CHIP
0
100K
1K
5%
5%
5%
1/10W
1/10W
(C8500R)
1/16W
1/16W
1/10W
R518
R519
R520
R521
R522
1-216-833-11
1-216-809-11
1-216-049-11
1-216-809-11
1-216-833-11
10K
100
1K
100
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/10W
1/16W
1/16W
R523
R524
R526
1-216-821-11 METAL CHIP
1-216-821-11 METAL CHIP
1-216-821-11 METAL CHIP
1K
1K
1K
5%
5%
5%
1/16W
1/16W
1/16W
R377
1-216-001-00 METAL CHIP
10
5%
R378
1-216-001-00 METAL CHIP
10
5%
R379
1-216-001-00 METAL CHIP
10
5%
R380
1-216-001-00 METAL CHIP
10
5%
R381
1-216-001-00 METAL CHIP
10
5%
R382
1-216-041-11 METAL CHIP
470
5%
R383
1-216-041-11 METAL CHIP
470
5%
R384
1-216-041-11 METAL CHIP
470
5%
R385
1-216-041-11 METAL CHIP
470
5%
R386
1-216-041-11 METAL CHIP
470
5%
R387
1-216-809-11 METAL CHIP
100
5%
R387
1-216-817-11 METAL CHIP
470
5%
R388
1-216-809-11 METAL CHIP
100
5%
R388
1-216-817-11 METAL CHIP
470
5%
R389
1-216-809-11 METAL CHIP
100
5%
R389
1-216-817-11 METAL CHIP
470
5%
R390
1-216-833-11 RES, CHIP
10K
5%
72
Ref. No.
1/10W
(C8500X)
1/10W
(C8500X)
1/10W
(C8500X)
1/10W
(C8500X)
1/10W
(C8500X)
1/10W
(C8500X)
1/10W
(C8500X)
1/10W
(C8500X)
1/10W
(C8500X)
1/10W
(C8500X)
1/16W
(C8500R)
1/16W
(C8500X)
1/16W
(C8500R)
1/16W
(C8500X)
1/16W
(C8500R)
1/16W
(C8500X)
1/16W
(C8500R)
RES, CHIP
SHORT
RES, CHIP
RES, CHIP
RES, CHIP
METAL CHIP
RES, CHIP
METAL CHIP
RES, CHIP
1/16W
(C8500X)
1/10W
(C8500R)
1/16W
(C8500R)
1/16W
(C8500X)
1/16W
(C8500R)
1/16W
(C8500X)
1/10W
(C8500X)
5%
1/16W
5%
1/10W
5%
1/16W
(C8500R: TYPE C)
0
5%
1/16W
(C8500X, C8500R: TYPE A)
100K
5%
1/16W
(C8500R: TYPE C)
10K
5%
1/16W
(C8500R: TYPE B)
100
5%
1/10W
0 (C8500R)
1K
5%
1/10W
1K
5%
1/10W
1/10W
1/10W
1/10W
(C8500R)
1/16W
(C8500X)
1/16W
MAIN
Ref. No.
Part No.
Description
Remark
R527
R528
1-216-815-11 METAL CHIP
1-216-821-11 METAL CHIP
330
1K
5%
5%
1/16W
1/16W
R529
R530
R531
R532
R533
1-216-049-11
1-216-845-11
1-216-821-11
1-216-821-11
1-216-809-11
RES, CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
100K
1K
1K
100
5%
5%
5%
5%
5%
1/10W
1/16W
1/16W
1/16W
1/16W
R534
R535
R536
R537
R538
1-216-845-11
1-216-821-11
1-216-821-11
1-216-845-11
1-216-049-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
RES, CHIP
100K
1K
1K
100K
1K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/10W
R540
R541
1-216-069-11 METAL CHIP
1-216-097-00 RES, CHIP
6.8K
100K
5%
5%
R542
R543
R544
1-216-833-11 RES, CHIP
1-216-097-00 RES, CHIP
1-216-845-11 METAL CHIP
10K
100K
100K
5%
5%
5%
1/10W
1/10W
(C8500R)
1/16W
1/10W
1/16W
R546
R547
1-216-097-00 RES, CHIP
1-216-845-11 METAL CHIP
100K
100K
5%
5%
R548
R549
R550
1-216-845-11 METAL CHIP
1-216-049-11 RES, CHIP
1-216-845-11 METAL CHIP
100K
1K
100K
5%
5%
5%
1/10W
1/16W
(C8500X)
1/16W
1/10W
1/16W
R551
R601
R602
R603
R604
1-216-825-11
1-216-089-00
1-216-845-11
1-216-025-00
1-216-295-00
METAL CHIP
RES, CHIP
METAL CHIP
RES, CHIP
SHORT
2.2K
47K
100K
100
0
5%
5%
5%
5%
1/16W
1/10W
1/16W
1/10W
R605
R606
R607
R608
R609
1-216-025-00
1-216-097-00
1-216-845-11
1-216-825-11
1-216-833-11
RES, CHIP
RES, CHIP
METAL CHIP
METAL CHIP
RES, CHIP
100
100K
100K
2.2K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/16W
1/16W
1/16W
R610
R611
R612
R614
R615
1-216-025-00
1-216-841-11
1-216-089-00
1-216-298-00
1-216-073-00
RES, CHIP
METAL CHIP
RES, CHIP
METAL CHIP
METAL CHIP
100
47K
47K
2.2
10K
5%
5%
5%
5%
5%
1/10W
1/16W
1/10W
1/10W
1/10W
R616
R617
R618
R701
R702
1-208-806-11
1-216-025-00
1-216-025-00
1-218-871-11
1-218-871-11
METAL CHIP
RES, CHIP
RES, CHIP
METAL CHIP
METAL CHIP
10K
100
100
10K
10K
0.5%
5%
5%
0.5%
0.5%
1/10W
1/10W
1/10W
1/16W
1/16W
R703
R704
R705
R706
R707
1-216-829-11
1-216-829-11
1-216-833-11
1-216-041-00
1-216-809-11
METAL CHIP
METAL CHIP
RES, CHIP
METAL CHIP
METAL CHIP
4.7K
4.7K
10K
470
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/10W
1/16W
R708
R709
R710
R711
R712
1-216-821-11
1-216-821-11
1-216-821-11
1-216-821-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
1K
1K
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R713
R714
R715
R716
1-216-295-00
1-216-049-11
1-216-864-11
1-216-845-11
SHORT
RES, CHIP
METAL CHIP
METAL CHIP
0
1K
0
100K
Ref. No.
Part No.
SENSOR
SERVO
Description
Remark
R717
1-216-809-11 METAL CHIP
100
5%
1/16W
R718
R719
R720
R721
R722
1-216-025-00
1-216-821-11
1-216-049-11
1-216-025-00
1-216-845-11
RES, CHIP
METAL CHIP
RES, CHIP
RES, CHIP
METAL CHIP
100
1K
1K
100
100K
5%
5%
5%
5%
5%
1/10W
1/16W
1/10W
1/10W
1/16W
R723
R724
R725
R726
R727
1-216-025-00
1-216-809-11
1-216-845-11
1-216-821-11
1-216-809-11
RES, CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100K
1K
100
5%
5%
5%
5%
5%
1/10W
1/16W
1/16W
1/16W
1/16W
R728
R729
R731
R732
R734
1-216-809-11
1-216-821-11
1-216-049-11
1-216-819-11
1-216-845-11
METAL CHIP
METAL CHIP
RES, CHIP
METAL CHIP
METAL CHIP
100
1K
1K
680
100K
5%
5%
5%
5%
5%
1/16W
1/16W
1/10W
1/16W
1/16W
R735
R736
R737
R738
R739
1-216-864-11
1-216-025-00
1-216-025-00
1-216-025-00
1-216-845-11
METAL CHIP
RES, CHIP
RES, CHIP
RES, CHIP
METAL CHIP
0
100
100
100
100K
5%
5%
5%
5%
5%
1/16W
1/10W
1/10W
1/10W
1/16W
R740
R741
R742
R743
R744
1-216-845-11
1-216-845-11
1-216-821-11
1-216-864-11
1-216-295-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
SHORT
100K
100K
1K
0
0
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
< SWITCH >
S101
S102
1-692-431-21 SWITCH, TACTILE (RESET)
1-771-540-11 SWITCH, PUSH (1KEY) (NOSE DETECT)
< THERMISTOR >
TH101
TH102
TH103
1-801-792-21 THERMISTOR, POSITIVE
1-810-940-11 THERMISTOR, POSITIVE
1-810-940-11 THERMISTOR, POSITIVE
< TUNER UNIT >
TUX201 A-3320-738-A TUNER UNIT (TUX-020)
< VIBRATOR >
X101
1-767-853-21 VIBRATOR, CRYSTAL (4.332MHz) (C8500R)
X103
1-567-098-41 VIBRATOR, CRYSTAL (32.768kHz)
X104
1-781-844-11 VIBRATOR, CRYSTAL (3.68MHz)
X105
1-781-822-21 VIBRATOR, CERAMIC (18.432MHz)
**************************************************************
A-3326-037-A SENSOR BOARD, COMPLETE
************************
For the parts on the SENSOR board, replace the entire mounted board.
**************************************************************
A-3326-039-A SERVO BOARD, COMPLETE
**********************
*
< CAPACITOR >
5%
5%
5%
1/10W
1/16W
1/16W
C11
C301
C302
1-162-964-11 CERAMIC CHIP
1-107-826-11 CERAMIC CHIP
1-107-826-11 CERAMIC CHIP
0.001uF
0.1uF
0.1uF
10%
10%
10%
50V
16V
16V
73
SERVO
Ref. No.
Part No.
Description
Remark
C305
C306
1-162-970-11 CERAMIC CHIP
1-107-823-11 CERAMIC CHIP
0.01uF
0.47uF
10%
10%
25V
16V
C307
C308
C309
C310
C311
1-107-826-11
1-162-927-11
1-162-968-11
1-107-823-11
1-164-245-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
100PF
0.0047uF
0.47uF
0.015uF
10%
5%
10%
10%
10%
16V
50V
50V
16V
25V
C314
C315
C316
C317
C318
1-107-826-11
1-109-982-11
1-107-826-11
1-107-826-11
1-104-852-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
TANTALUM CHIP
0.1uF
1uF
0.1uF
0.1uF
22uF
10%
10%
10%
10%
20%
16V
10V
16V
16V
6.3V
C319
C320
C321
C322
C324
1-104-852-11
1-164-227-11
1-162-969-11
1-162-964-11
1-107-826-11
TANTALUM CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
22uF
0.022uF
0.0068uF
0.001uF
0.1uF
20%
10%
10%
10%
10%
6.3V
25V
25V
50V
16V
C325
C326
C327
C328
C329
1-110-563-11
1-162-968-11
1-109-982-11
1-162-966-11
1-164-227-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.068uF
0.0047uF
1uF
0.0022uF
0.022uF
10%
10%
10%
10%
10%
16V
50V
10V
50V
25V
C330
C331
C333
C336
C339
1-162-970-11
1-107-826-11
1-107-826-11
1-162-970-11
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.1uF
0.1uF
0.01uF
0.01uF
10%
10%
10%
10%
10%
25V
16V
16V
25V
25V
C342
C343
C344
C345
C346
1-162-970-11
1-162-970-11
1-104-852-11
1-162-970-11
1-104-852-11
CERAMIC CHIP
CERAMIC CHIP
TANTALUM CHIP
CERAMIC CHIP
TANTALUM CHIP
0.01uF
0.01uF
22uF
0.01uF
22uF
10%
10%
20%
10%
20%
25V
25V
6.3V
25V
6.3V
C347
C348
C349
C350
C351
1-162-970-11
1-107-826-11
1-107-826-11
1-107-826-11
1-104-852-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
TANTALUM CHIP
0.01uF
0.1uF
0.1uF
0.1uF
22uF
10%
10%
10%
10%
20%
25V
16V
16V
16V
10V
C352
C353
C356
C357
C358
1-107-826-11
1-107-826-11
1-162-927-11
1-162-927-11
1-162-927-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
100PF
100PF
100PF
10%
10%
5%
5%
5%
16V
16V
50V
50V
50V
C359
C361
C362
C402
C403
1-162-923-11
1-135-259-11
1-107-826-11
1-162-970-11
1-107-826-11
CERAMIC CHIP
TANTALUM CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
47PF
10uF
0.1uF
0.01uF
0.1uF
5%
20%
10%
10%
10%
50V
6.3V
16V
25V
16V
C501
C503
C504
C505
C506
1-162-927-11
1-107-826-11
1-107-826-11
1-107-826-11
1-104-852-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
TANTALUM CHIP
100PF
0.1uF
0.1uF
0.1uF
22uF
5%
10%
10%
10%
20%
50V
16V
16V
16V
10V
C510
C511
C512
C513
C514
1-115-467-11
1-107-826-11
1-107-826-11
1-107-826-11
1-115-467-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.22uF
0.1uF
0.1uF
0.1uF
0.22uF
10%
10%
10%
10%
10%
10V
16V
16V
16V
10V
Ref. No.
C515
C516
Part No.
Description
Remark
1-107-826-11 CERAMIC CHIP
1-107-826-11 CERAMIC CHIP
0.1uF
0.1uF
10%
10%
16V
16V
< CONNECTOR >
CN101
CN102
CN103
1-764-616-12 HOUSING, CONNECTOR (PC BOARD) 30P
1-573-929-21 CONNECTOR, FFC/FPC (ZIF) 20P
1-764-439-21 CONNECTOR, FPC 11P
< DIODE >
D401
D501
8-719-157-93 DIODE DTZ-TT11-3.0B
8-719-988-61 DIODE 1SS355TE-17
< FERRITE BEAD >
74
FB302
1-414-760-21 FERRITE BEAD INDUCTOR CHIP
< IC >
IC301
IC302
IC303
IC304
IC305
8-752-384-47
8-752-080-95
8-759-430-25
8-759-096-87
8-759-040-83
IC
IC
IC
IC
IC
CXD2652AR
CXA2523AR
BH6511FS
TC7WU04FU (TE12R)
BA6287F
IC306
IC307
IC401
IC501
IC502
8-759-058-62
8-759-368-16
8-759-909-71
8-752-909-21
8-759-238-47
IC
IC
IC
IC
IC
TC7S08FU (TE85R)
MN41V4400TT-08S
BA4558F-E2
CXP84340-217Q
TC74HCT7007AF (EL)
IC503
8-759-238-47 IC TC74HCT7007AF (EL)
< COIL/SHORT >
L301
L302
L303
L304
L305
1-412-058-11
1-412-058-11
1-219-365-11
1-219-365-11
1-219-365-11
INDUCTOR CHIP
INDUCTOR CHIP
SHORT
SHORT
SHORT
10uH
10uH
0
0
0
L306
L501
1-219-365-11 SHORT
0
1-412-058-11 INDUCTOR CHIP 10uH
< TRANSISTOR >
Q301
Q302
Q401
Q402
Q403
8-729-230-49
8-729-026-49
8-729-920-85
8-729-106-60
8-729-421-22
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC2712Y-TE85L
2SA1037AK-T146-QR
2SD1664-T101-QR
2SB1132-T101-QR
UN2211-TX
< RESISTOR >
R301
R302
R303
R304
R305
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
100
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R306
R307
R308
R311
R313
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
100
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R314
R318
1-216-809-11 METAL CHIP
1-216-833-11 RES, CHIP
100
10K
5%
5%
1/16W
1/16W
SERVO
Ref. No.
Part No.
Description
Remark
R319
R320
R324
1-216-845-11 METAL CHIP
1-216-855-11 METAL CHIP
1-216-827-11 METAL CHIP
100K
680K
3.3K
5%
5%
5%
1/16W
1/16W
1/16W
R325
R327
R328
R329
R330
1-216-821-11
1-216-821-11
1-216-811-11
1-216-819-11
1-216-853-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
150
680
470K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R331
R332
R333
R334
R335
1-216-809-11
1-216-809-11
1-216-819-11
1-216-809-11
1-216-815-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
680
100
330
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R336
R337
R338
R339
R340
1-216-853-11
1-216-853-11
1-216-833-11
1-216-827-11
1-216-843-11
METAL CHIP
METAL CHIP
RES, CHIP
METAL CHIP
METAL CHIP
470K
470K
10K
3.3K
68K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R341
R342
R343
R344
R345
1-216-837-11
1-216-833-11
1-216-827-11
1-216-833-11
1-216-827-11
METAL CHIP
RES, CHIP
METAL CHIP
RES, CHIP
METAL CHIP
22K
10K
3.3K
10K
3.3K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R346
R347
R348
R349
R350
1-216-841-11
1-216-833-11
1-218-863-11
1-216-025-00
1-216-142-00
METAL CHIP
RES, CHIP
METAL CHIP
RES, CHIP
RES, CHIP
47K
10K
4.7K
100
4.7
5%
5%
0.5%
5%
5%
1/16W
1/16W
1/16W
1/10W
1/8W
R351
R352
R353
R354
R355
1-218-855-11
1-218-855-11
1-218-855-11
1-216-857-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
RES, CHIP
2.2K
2.2K
2.2K
1M
10K
0.5%
0.5%
0.5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R356
R357
R358
R401
R402
1-216-833-11
1-216-017-00
1-216-864-11
1-216-073-00
1-216-065-00
RES, CHIP
RES, CHIP
METAL CHIP
METAL CHIP
RES, CHIP
10K
47
0
10K
4.7K
5%
5%
5%
5%
5%
1/16W
1/10W
1/16W
1/10W
1/10W
R403
R404
R405
R406
R501
1-216-065-00
1-216-809-11
1-218-847-11
1-218-869-11
1-216-821-11
RES, CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
100
1K
8.2K
1K
5%
5%
0.5%
0.5%
5%
1/10W
1/16W
1/16W
1/16W
1/16W
R502
R503
R504
R505
R506
1-216-821-11
1-216-821-11
1-216-821-11
1-216-821-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
1K
1K
100K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R507
R510
R511
R512
R516
1-218-863-11
1-216-864-11
1-216-845-11
1-216-847-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
0
100K
150K
100
0.5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R517
R518
R519
R520
R521
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
100
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
Ref. No.
SUB
Part No.
Description
Remark
R522
R523
R524
R525
R526
1-216-821-11
1-216-821-11
1-216-821-11
1-216-845-11
1-216-825-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
1K
100K
2.2K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R527
R528
R529
R531
R532
1-216-825-11
1-216-825-11
1-216-825-11
1-216-845-11
1-216-864-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
2.2K
2.2K
100K
0
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R533
R534
R535
R536
R537
1-216-845-11
1-216-845-11
1-216-845-11
1-216-864-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
100K
100K
0
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R538
R539
R540
R542
R547
1-216-845-11
1-216-845-11
1-216-845-11
1-216-845-11
1-216-864-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
100K
100K
100K
0
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
< COMPOSITION CIRCUIT BLOCK >
RB301
RB302
RB503
1-233-576-11 RES, CHIP NETWORK 100
1-233-576-11 RES, CHIP NETWORK 100
1-233-412-11 RES, CHIP NETWORK 1K (3216)
< THERMISTOR >
TH501
1-810-421-11 THERMISTOR NTH5G36B103K01TE
< VIBRATOR >
X501
1-760-365-11 VIBRATOR, CERAMIC (10MHz)
**************************************************************
1-677-865-11 SUB BOARD
**********
*
< CONNECTOR >
CN751
CN752
1-794-064-11 SOCKET, CONNECTOR 14P
1-770-736-21 SOCKET, CONNECTOR 14P
< LED >
LED751 8-719-077-75 LED BR1101F-TR (MD DISC SLOT) (C8500X)
LED751 8-719-077-78 LED BG1101F-TR (MD DISC SLOT) (C8500R)
< SWITCH >
LSW751 1-771-609-11 SWITCH, TACTILE (WITH LED) (Z) (C8500R)
LSW751 1-771-883-11 SWITCH, TACTILE (WITH LED) (Z) (C8500X)
< TRANSISTOR >
Q751
Q752
8-729-421-22 TRANSISTOR UN2211-TX
8-729-903-46 TRANSISTOR 2SB1132-T100-QR
< RESISTOR >
R751
R752
R753
1-216-025-00 RES, CHIP
1-216-049-11 RES, CHIP
1-216-049-11 RES, CHIP
100
1K
1K
5%
5%
5%
1/10W
1/10W
1/10W
75
MDX-C8500R/C8500X
Ver 1.1 2001.05
SUB
Ref. No.
R754
Part No.
Description
Remark
1/8W
(C8500R)
R754
1-216-194-00 METAL CHIP
680
5%
1/8W
(C8500X)
**************************************************************
MISCELLANEOUS
**************
17
17
23
60
153
0 165
F1
LCD901
LCD901
M901
1-216-186-00 RES, CHIP
330
1-776-527-71 CORD (WITH CONNECTOR) (ISO) (POWER)
(C8500R)
1-792-194-11 CORD (WITH CONNECTOR) (POWER) (C8500X)
1-792-602-11 CORD (WITH CONNECTOR) (SUB OUT)
1-694-660-11 CONDUCTIVE BOARD, CONNECTION
1-654-693-11 SENSOR FLEXIBLE BOARD
8-583-065-03
1-532-877-11
1-803-915-11
1-803-915-21
A-3301-407-A
Ref. No.
Part No.
5%
OPTICAL PICK-UP KMS-241C/J1RP
FUSE (BLADE TYPE) (AUTO FUSE) (10A)
DISPLAY PANEL, LIQUID CRYSTAL (C8500R)
DISPLAY PANEL, LIQUID CRYSTAL (C8500X)
MOTOR ASSY, SP (SPINDLE)
Description
Remark
PARTS FOR INSTALLATION AND CONNECTION
*************************************
501
502
503
504
505
3-012-360-31
3-040-979-01
3-233-644-01
X-3366-405-1
X-3368-725-1
506
507
X-3371-913-1 SCREW ASSY (J) (C8500R)
1-776-527-71 CORD (WITH CONNECTOR) (ISO) (POWER)
(C8500R)
1-792-194-11 CORD (WITH CONNECTOR) (POWER)
(C8500X)
1-465-459-21 ADAPTOR, ANTENNA (C8500R)
3-924-961-01 SUPPORT (ND), FITTING (C8500X)
507
508
509
FRAME
COLLAR
SPRING, FITTING
SCREW ASSY (EXP), FITTING (C8500R)
SCREW ASSY, FITTING (C8500X)
502
501
503
M902
A-3291-190-A MOTOR ASSY, SL (SLED)
M903
A-3291-191-A MOTOR ASSY, LO (LOADING)
************************************************************
**************
HARDWARE LIST
**************
#1
#2
#3
#4
#5
7-621-772-20
7-685-795-09
7-685-794-09
7-685-792-09
7-685-851-04
SCREW +B 2X5
SCREW +PTT 2.6X12 (S)
SCREW +PTT 2.6X10 (S)
SCREW +PTT 2.6X6 (S)
SCREW +BVTT 2X4 (S)
#6
#7
#8
#9
#10
7-624-102-04
7-627-852-37
7-621-772-08
7-621-555-10
7-685-793-09
STOP RING 1.5, TYPE -E
PRECISION SCREW +P 1.7X1.8 TYPE3
SCREW +B 2X3
SCREW +K 2X3
SCREW +PTT 2.6X8 (S)
FRAME
×1
COLLAR
×1
SPRING, FITTING
×2
505
504
SCREW, FITTING
×1
BUSHING
×1
506
+P4 × 6
×1
C8500R
C8500X
507
507
+T4 × 12
×1
#12
7-627-553-28 SCREW, PRECISION +P 2X2.5
#13
7-685-106-19 SCREW +P 2X10 TYPE2 NON-SLIT
************************************************************
ACCESSORIESE & PACKING MATERIALS
*********************************
1-418-812-11 REMOTE COMMANDER (RM-X91) (C8500X)
3-044-623-01 LID, BATTERY CASE (for RM-X91) (C8500X)
3-045-190-11 MANUAL, INSTRUCTION
(ENGLISH, FRENCH, SPANISH) (US)
3-045-191-11 MANUAL, INSTRUCTION (ENGLISH, SPANISH,
SWEDISH, PORTUGUESE, RUSSIAN) (AEP, UK)
3-045-191-21 MANUAL, INSTRUCTION (FRENCH, GERMAN,
DUTCH, ITALIAN, GREEK) (AEP)
3-045-191-31 MANUAL, INSTRUCTION (GERMAN) (German)
3-045-193-11 MANUAL, INSTRUCTION, INSTALL
(ENGLISH, FRENCH, SPANISH) (US)
3-045-194-11 MANUAL, INSTRUCTION, INSTALL
(ENGLISH, SPANISH, SWEDISH,
PORTUGUESE, RUSSIAN) (AEP, UK)
3-045-194-21 MANUAL, INSTRUCTION, INSTALL
(FRENCH, GERMAN, DUTCH, ITALIAN,
GREEK) (Greman, AEP)
X-3378-490-1 CASE (PANEL) ASSY
************************************************************
76
+K5 × 8
×5
508
ADAPTOR, ANTENNA
×1
POWER CORD
×1
POWER CORD
×1
509
SUPPORT (ND), FITTING
×1
The components identified by mark 0 or dotted
line with mark 0 are critical for safety.
Replace only with part number specified.
MDX-C8500R/C8500X
US Model
MDX-C8500X
AEP Model
UK Model
SERVICE MANUAL
MDX-C8500R
SUPPLEMENT-1
File this supplement with the service manual.
Subject:
1. Correction
2. Board Modification
(ECN-CSA02398/CSA02816/CSA02817)
TABLE OF CONTENTS
1.
CORRECTION .................................................................. 2
2.
BOARD MODIFICATION
2-1. New/Former Type Discrimination .........................................
2-2. Servicing notes .......................................................................
2-3. Notes for Printed Wiring Boards and
Schematic Diagrams ..............................................................
2-4. Printed Wiring Board
– MAIN Board (Component Side) – .....................................
2-5. Printed Wiring Board
– MAIN Board (Conductor Side) – .......................................
2-6. Schematic Diagram – MAIN Board (1/4) – ..........................
2-7. Schematic Diagram – MAIN Board (2/4) – ..........................
2-8. Schematic Diagram – MAIN Board (3/4) – ..........................
2-9. Schematic Diagram – MAIN Board (4/4) – ..........................
2-10. Printed Wiring Board – DSO Board – ...................................
2-11. Schematic Diagram – DSO Board – ......................................
2-12. Printed Wiring Board – SUB Board – ...................................
2-13. Schematic Diagram – SUB Board – ......................................
2-14. Printed Wiring Board – KEY Board – ...................................
2-15. Schematic Diagram – KEY Board – .....................................
2-16. Exploded Views ......................................................................
2-17. Electrical Parts List ................................................................
6
7
7
8
9
10
11
12
13
14
15
16
17
18
19
20
20
1. CORRECTION
• DISASSEMBLY
! : Indicates corrected portion.
Page
INCORRECT
SUB PANEL ASS’Y
CORRECT
1 screw
(PTT2.6 × 6)
1 screw
(PTT2.6 × 5)
$
2 cover
2 cover
SUB PANEL ASS’Y
^
3 screw
(PTT2.6 × 8)
3 screw
(PTT2.6 × 6)
^
3 two screws
(PTT2.6 × 8)
3 two screws
(PTT2.6 × 6)
SUB PANEL ASS’Y
4 claw
4 claw
5 connector (CN752)
5 connector (CN752)
^
3 screw
(PTT2.6 × 6)
3 screw
(PTT2.6 × 8)
11
MECHANISM DECK (MG-164NV-138)
3 two screws
(PTT2.6 × 10)
3 two screws
(PTT2.6 × 5)
#
5 mechanism deck
(MG-164NV-138)
5 mechanism deck
(MG-164NV-138)
1 screw
(PTT2.6 × 6)
2 c
(C
1 screw
(PTT2.6 × 5)
$
2 co
(C
MECHANISM DECK (MG-164NV-138)
1 screw
(PTT2.6 × 6)
2
1 screw
(PTT2.6 × 5)
#
• EXPLODED VIEWS
! : Indicates corrected portion.
Page
INCORRECT
Ref. No. Part No.
* 15
CORRECT
Description
Remark
3-040-996-01 HEAT SINK (2P)
Ref. No. Part No.
Description
Remark
* 15
3-040-996-32 HEAT SINK (2P) (C8500R)
* 15
3-040-996-72 HEAT SINK (2P) (C8500X)
$
$
$
23
1-792-602-11 CORD (WITH CONNECTOR) (SUB OUT)
23
1-790-355-52 CORD (WITH CONNECTOR) (RCA)
(SUB OUT)
$
* 28
3-049-439-02 SHEET (IC), RADIATION
* 29
3-049-650-01 SHEET (TR), RADIATION (C8500R)
* 30
3-049-651-01 SHEET (B), RADIATION (C8500R)
$
$
$
^
#3
#14
13
13
B
B
11
11
59
27
8
12
24
1
27
8
12
1
24
26
25
26
9
25
#
9
TUX201
#
#4
TUX201
28
#
3
3
4
7
8
4
7
%29 ^
#14
8
#14
#4
14
#3
30
@
14
#3
– Continued on next page –
3
Page
INCORRECT
CORRECT
%
6
#10
6
#4
#1
#1
#10
#1
Front panel section
#
#10
#4
#1
#4
Front panel section
1
1
B
#
B
A
A
59
#4
#14
18
#12
Ref. No. Part No.
65
18
#12
19
Description
Remark
3-935-151-01 SPRING (OPEN)
Ref. No. Part No.
65
#
19
Description
Remark
3-037-267-01 SPRING (OPEN)
$
60
59
59
61
60
60
66
4
LCD901
60
66
LCD901
$
61
• ELECTRICAL PARTS LIST
! : Indicates corrected portion.
Page
INCORRECT
Ref. No. Part No.
Description
CORRECT
Remark
Ref. No. Part No.
63
Description
Remark
3-045-994-01 COVER (DSP), SHIELD
*
$
3-040-996-01 HEAT SINK (2P)
*
*
3-040-996-32 HEAT SINK (2P) (C8500R)
*
3-040-996-72 HEAT SINK (2P) (C8500X)
$
66
$
$
3-045-994-01 COVER (DSP), SHIELD
*
MISCELLANEOUS
***************
23
1-792-602-11 CORD (WITH CONNECTOR) (SUB OUT)
MISCELLANEOUS
***************
23
1-790-335-52 CORD (WITH CONNECTOR) (RCA)
(SUB OUT)
$
************************************************************
***************
HARD WARE LIST
***************
************************************************************
***************
HARD WARE LIST
***************
#2
7-685-795-09 SCREW+PTT2.6×12 (S)
#2
7-685-793-09 SCREW+PTT2.6×8 (S)
#10
7-685-793-09 SCREW+PTT2.6×8 (S)
#10
7-685-795-09 SCREW+PTT2.6×12 (S)
#14
7-685-791-09 SCREW+PTT2.6×5 (S)
$
$
$
$
$
************************************************************
ACCESSORIES & PACKING MATERIALS
********************************
************************************************************
ACCESSORIES & PACKING MATERIALS
********************************
3-045-191-11 MANUAL, INSTRUCTION
(ENGLISH, SPANISH, SWEDISH,
PORTUGUESE, RUSSIAN) (AEP, UK)
3-045-187-11 MANUAL, INSTRUCTION
(ENGLISH, SPANISH, SWEDISH,
PORTUGUESE, RUSSIAN) (AEP, UK)
3-045-191-21 MANUAL, INSTRUCTION
(FRENCH, GERMAN, DUTCH,
ITALIAN, GREEK) (AEP)
3-045-187-21 MANUAL, INSTRUCTION
(FRENCH, GERMAN, DUTCH,
ITALIAN, GREEK) (AEP)
3-045-191-31 MANUAL, INSTRUCTION
(GERMAN) (German)
3-045-187-31 MANUAL, INSTRUCTION
(GERMAN) (German)
3-045-194-11 MANUAL, INSTRUCTION, INSTALL
(ENGLISH, SPANISH, SWEDISH,
PORTUGUESE, RUSSIAN) (AEP, UK)
3-045-198-11 MANUAL, INSTRUCTION, INSTALL
(ENGLISH, SPANISH, SWEDISH,
PORTUGUESE, RUSSIAN) (AEP, UK)
3-045-194-21 MANUAL, INSTRUCTION, INSTALL
(FRENCH, GERMAN, DUTCH,
ITALIAN, GREEK) (Greman, AEP)
************************************************************
PARTS FOR INSTALLATION AND CONNECTION
**************************************
3-045-198-21 MANUAL, INSTRUCTION, INSTALL
(FRENCH, GERMAN, DUTCH,
ITALIAN, GREEK) (German, AEP)
************************************************************
PARTS FOR INSTALLATION AND CONNECTION
**************************************
76
$
$
$
$
$
501
3-012-360-31 FRAME
501
X-3373-602-1 FRAME ASSY
506
X-3371-913-1 SCREW ASSY (J) (C8500R)
506
3-934-325-01 SCREW +K (5×8) TAPPING
$
$
5
2. BOARD MODIFICATION
In this set, MAIN, DSO, SUB and KEY boards have been changed in the midway of production.
This supplement contains only a difference portion.
2-1.
New/Former Type Discrimination
– MAIN BOARD (Component Side) –
Former Type : 1-677-862-11
New Type : 1-677-862-12
– SUB BOARD (Component Side) –
Former Type : 1-677-865-11
New Type : 1-677-865-12
– DSO BOARD (Component Side) –
Former Type : 1-677-864-11
New Type : 1-677-864-12
– KEY BOARD (Conductor Side) –
Former Type : 1-677-058-12
New Type : 1-677-058-13
6
2-2.
SERVICING NOTES
2-3.
• Model Identification
There are three types of main board in according of destination
for MDX-C8500R.
NOTE FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS
Note on Printed Wiring Board:
• X : parts extracted from the component side.
• Y : parts extracted from the conductor side.
f
: internal component.
•
• b : Pattern from the side which enables seeing.
(The other layers' patterns are not indicated.)
– MAIN BOARD (Component Side)
Caution:
Pattern face side:
(Conductor Side)
Parts face side:
(Component Side)
R502
R503
IC502
R502
R503
a
×
TYPE B
×
a
TYPE C
a
a
TYPE A
Type A, B and C can be identified by its model number label at
the buttom of the set.
– SPECIFICATION LABEL –
TYPE A
TYPE B
TYPE C
7
7
Parts on the pattern face side seen from
the pattern face are indicated.
Parts on the parts face side seen from
the parts face are indicated.
Note on Schematic Diagram:
• All capacitors are in µF unless otherwise noted. pF: µµF
50 WV or less are not indicated except for electrolytics
and tantalums.
• All resistors are in Ω and 1/4 W or less unless otherwise
specified.
f
: internal component.
•
• C : panel designation.
• U : B+ Line.
• Power voltage is dc 14.4V and fed with regulated dc power
supply from ACC and BATT cords.
• Voltages and waveforms are dc with respect to ground
under no-signal (detuned) conditions.
no mark : FM
(
) : AM(MW/LW)
[
] : LW
〈〈
〉〉 : MD PLAY
• Voltages are taken with a VOM (Input impedance 10 MΩ).
Voltage variations may be noted due to normal production tolerances.
• Waveforms are taken with a oscilloscope.
Voltage variations may be noted due to normal production tolerances.
• Circled numbers refer to waveforms.
• Signal path.
F : FM
f : AM(MW/LW)
L : BUS AUDIO IN
E : MD PLAY
• Please refer to servicing notes for system of TYPE A, B
and C.
MDX-C8500R/C8500X
2-4.
PRINTED WIRING BOARD – MAIN Board (Component Side) –
• Semiconductor Location
Ref. No.
Location
Ref. No.
Location
D101
D102
D104
D105
D106
D107
D108
D109
D201
D203
D204
D205
D301
D302
D352
D353
D354
D501
D601
D602
D603
D607
D608
D609
D610
D614
D701
D702
D703
D751
D752
D753
D754
D755
D756
D757
D758
D759
D760
D761
D762
I-4
I-4
H-5
F-8
B-2
B-1
K-3
J-3
G-12
F-11
F-11
F-12
C-6
D-7
C-8
C-7
C-8
H-11
G-7
H-7
F-8
F-7
G-7
F-7
G-7
G-8
J-12
I-11
I-13
K-12
J-12
K-13
J-11
K-11
J-12
J-12
K-13
K-13
J-13
K-11
J-13
IC503
IC504
IC601
IC701
IC702
J-5
K-5
G-7
J-10
H-11
IC201
IC202
IC301
IC302
IC303
IC304
IC305
IC502
H-12
F-12
G-10
I-3
D-9
D-11
D-10
I-7
Q101
Q102
Q103
Q106
Q108
Q109
Q111
Q112
Q113
Q201
Q203
Q204
Q208
Q209
Q351
Q352
Q353
Q354
Q355
Q356
Q357
Q358
Q359
Q360
Q361
Q363
Q364
Q365
Q366
Q404
Q405
Q407
Q601
Q602
Q603
Q604
Q605
Q701
Q702
Q703
Q705
Q901
Q902
Q903
I-4
H-4
H-4
H-4
E-8
E-8
K-7
J-4
K-4
G-13
E-12
E-11
F-11
F-13
K-3
C-8
C-7
C-6
C-7
B-10
B-10
B-11
B-11
C-11
D-12
C-5
C-5
D-5
D-4
E-5
F-5
F-5
G-7
H-7
F-7
F-8
D-2
J-12
J-13
I-13
H-13
I-13
J-13
J-13
8
8
2-5.
MDX-C8500R/C8500X
PRINTED WIRING BOARD – MAIN Board (Conductor Side) –
6
5
8
3
4
7
2
1
(FRONT VIEW)
(C8500R)
GRN
TO
CN101
WHT
GRY
VIO
WHT
GRN
VIO
GRY
RL+
RL–
FL+
FL–
FR+
FR–
RR+
RR–
1
9
2
10
3
11
4
12
5
13
6
14
7
15
8
16
ACC
GND
GRN/BLK
WHT/BLK
GRY/BLK
VIO/BLK
WHT/BLK
GRN/BLK
VIO/BLK
GRY/BLK
LIGHT BLU
ATT
BLU/WHT
BLU
RED
BLK
RED
YEL
ILL
BLU
ANT REM
AMP REM
ORG/WHT
NC
BATT
NC
NC
BLK
ORG/WHT
YEL
(C8500X)
1
9
2
10
3
11
4
12
WHT/BLK
WHT
GRN/BLK
GRN
VIO/BLK
VIO
GRY/BLK
GRY
5
13
LIGHT BLU
BLU/WHT
6
14
ORG/WHT
BLU
7
FRONT LCH (+)
REAR LCH (–)
REAR LCH (+)
REAR RCH (–)
REAR RCH (+)
FRONT RCH (–)
FRONT RCH (+)
ATT
AMP REM
ILL IN
ANT REM
15
RED
8
FRONT LCH (–)
16
YEL
BLK
(Page 14)
ACC
BATT
GND
• Semiconductor
Location
Ref. No.
(Page 16)
9
9
Location
D103
D355
D356
D357
D358
D359
D360
D361
D362
D363
D502
D604
D605
D606
D611
D612
D613
G-3
C-7
C-7
C-6
C-6
B-8
B-7
B-8
B-8
C-2
J-8
C-2
B-2
C-2
D-1
D-2
D-2
IC351
B-7
Q104
Q105
Q107
Q110
Q401
Q406
Q704
F-4
G-3
E-8
B-1
E-4
F-5
J-13
MDX-C8500R/C8500X
2-6.
SCHEMATIC DIAGRAM – MAIN Board (1/4) –
(Page 15)
(Page 11)
(Page 12)
10
10
MDX-C8500R/C8500X
2-7.
SCHEMATIC DIAGRAM – MAIN Board (2/4) –
(Page
10)
(Page 12)
(Page 13)
11
11
MDX-C8500R/C8500X
2-8.
SCHEMATIC DIAGRAM – MAIN Board (3/4) –
(Page 10)
(Page 11)
(Page 13)
12
12
MDX-C8500R/C8500X
2-9.
SCHEMATIC DIAGRAM – MAIN Board (4/4) –
(Page 11)
(Page
12)
(Page 17)
13
13
MDX-C8500R/C8500X
2-10. PRINTED WIRING BOARD – DSO Board –
(Page 9)
• Semiconductor
Location
Ref. No.
• Semiconductor
Location
Location
D804
B-5
IC801
IC803
IC806
IC809
A-2
B-3
B-1
B-5
Q801
A-3
Ref. No.
14
14
Location
D802
C-1
IC802
IC805
IC807
IC808
B-1
B-3
A-5
B-5
MDX-C8500R/C8500X
2-11. SCHEMATIC DIAGRAM – DSO Board –
(Page
10)
• Voltages and waveforms are dc with respect to ground
under no-signal conditions.
no mark : MD PLAY
: Impossible to measure
∗
15
15
MDX-C8500R/C8500X
2-12. PRINTED WIRING BOARD – SUB Board –
(Page 9)
(Page 18)
16
16
MDX-C8500R/C8500X
2-13. SCHEMATIC DIAGRAM – SUB Board –
(Page 19)
(Page 13)
17
17
MDX-C8500R/C8500X
2-14. PRINTED WIRING BOARD – KEY Board –
• Semiconductor
Location
Ref. No.
Location
IC951
C-6
LED901
LED902
LED903
LED904
LED910
LED911
LED912
LED913
C-2
A-2
A-3
C-3
B-12
A-12
A-5
B-5
• Semiconductor
Location
Ref. No.
Location
D901
D902
D903
D904
D951
D952
D954
B-13
C-11
C-11
C-11
C-5
B-10
B-10
IC901
B-8
Q901
Q902
Q903
A-3
A-3
A-5
(Page 16)
18
18
MDX-C8500R/C8500X
2-15. SCHEMATIC DIAGRAM – KEY Board –
(Page
17)
19
19
DSO
2-16. EXPLODED VIEWS
2-17. ELECTRICAL PARTS LIST
! : Changed portion.
Page
Former type
Ref. No. Part No.
59
* 8
1-677-865-11 SUB BOARD
Remark
Ref. No. Part No.
* 8
Description
Remark
1-677-865-12 SUB BOARD
$
* 61
60
Description
New type
3-041-371-02 SHEET (REFLECTOR)
* 61
3-041-371-11 SHEET (REFLECTOR)
$
NOTE:
• Due to standardization, replacements in the
parts list may be different from the parts specified in the diagrams or the components used
on the set.
• -XX and -X mean standardized parts, so they
may have some difference from the original
one.
• RESISTORS
All resistors are in ohms.
METAL: Metal-film resistor.
METAL OXIDE: Metal oxide-film resistor.
F: nonflammable
• Please refer to servicing notes (page 7) for system of TYPE A, B and C.
Ref. No.
Part No.
*
A-3294-916-A DSO BOARD, COMPLETE
*********************
*
*
3-045-138-01 CASE (DSP), SHIELD
3-045-994-01 COVER (DSP), SHIELD
• Items marked “*” are not stocked since they
are seldom required for routine service.
Some delay should be anticipated when ordering these items.
• SEMICONDUCTORS
In each case, u: µ, for example:
uA. . : µA. .
uPA. . : µPA. .
uPB. . : µPB. .
uPC. . : µPC. .
uPD. . : µPD. .
• CAPACITORS
uF: µF
• COILS
uH: µH
Description
Remark
< CAPACITOR >
C801
C802
C803
C804
C805
1-126-393-11
1-126-392-11
1-126-394-11
1-117-709-11
1-107-826-11
ELECT CHIP
ELECT CHIP
ELECT CHIP
ELECT CHIP
CERAMIC CHIP
33uF
100uF
10uF
10uF
0.1uF
20%
20%
20%
20%
10%
10V
6.3V
16V
10V
16V
C806
C808
C809
C810
C811
1-107-826-11
1-162-924-11
1-162-917-11
1-128-993-21
1-128-993-21
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
ELECT CHIP
0.1uF
56PF
15PF
22uF
22uF
10%
5%
5%
20%
20%
16V
50V
50V
10V
10V
C812
C813
C814
C815
C816
1-107-826-11
1-107-826-11
1-107-826-11
1-107-826-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
10%
10%
10%
10%
10%
16V
16V
16V
16V
16V
C817
C818
C819
C820
C821
1-107-826-11
1-107-826-11
1-125-838-11
1-107-826-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
2.2uF
0.1uF
0.1uF
10%
10%
10%
10%
10%
16V
16V
6.3V
16V
16V
C822
C823
C824
C825
C826
1-128-415-11
1-107-826-11
1-126-393-11
1-107-826-11
1-126-392-11
ELECT CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
ELECT CHIP
68uF
0.1uF
33uF
0.1uF
100uF
20%
10%
20%
10%
20%
10V
16V
10V
16V
6.3V
C827
C828
C829
C830
C831
1-107-826-11
1-107-826-11
1-107-826-11
1-107-826-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
10%
10%
10%
10%
10%
16V
16V
16V
16V
16V
C834
C835
C836
C837
C838
1-107-826-11
1-107-826-11
1-107-826-11
1-107-826-11
1-162-965-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.1uF
0.0015uF
10%
10%
10%
10%
10%
16V
16V
16V
16V
50V
C839
C840
1-107-826-11 CERAMIC CHIP
1-126-394-11 ELECT CHIP
0.1uF
10uF
10%
20%
16V
16V
Ref. No.
Part No.
When indicating parts by reference
number, please include the board.
Description
Remark
C841
C842
C843
1-126-394-11 ELECT CHIP
1-126-394-11 ELECT CHIP
1-126-394-11 ELECT CHIP
10uF
10uF
10uF
20%
20%
20%
16V
16V
16V
C844
C845
C846
C847
C848
1-115-412-11
1-126-394-11
1-115-412-11
1-115-412-11
1-115-412-11
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
680PF
10uF
680PF
680PF
680PF
5%
20%
5%
5%
5%
25V
16V
25V
25V
25V
C849
C850
C851
C852
C853
1-115-412-11
1-115-412-11
1-115-412-11
1-115-412-11
1-115-412-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
680PF
680PF
680PF
680PF
680PF
5%
5%
5%
5%
5%
25V
25V
25V
25V
25V
C854
C855
C856
C857
C861
1-115-412-11
1-107-826-11
1-107-826-11
1-107-826-11
1-126-394-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
680PF
0.1uF
0.1uF
0.1uF
10uF
5%
10%
10%
10%
20%
25V
16V
16V
16V
16V
C862
C874
C875
C876
C877
1-107-826-11
1-164-230-11
1-164-230-11
1-164-230-11
1-164-230-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
220PF
220PF
220PF
220PF
10%
5%
5%
5%
5%
16V
50V
50V
50V
50V
C878
C879
C880
C881
C899
1-164-230-11
1-164-230-11
1-125-838-11
1-125-838-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
220PF
220PF
2.2uF
2.2uF
0.1uF
5%
5%
10%
10%
10%
50V
50V
6.3V
6.3V
16V
< CONNECTOR >
CN801
1-794-320-11 PIN, CONNECTOR (PC BOARD) 29P
< DIODE >
D802
D804
8-719-073-01 DIODE MA111-TX
8-719-421-82 DIODE MA8043-M (TX)
< FERRITE BEAD >
20
20
FB801
FB803
FB804
FB805
FB806
1-414-235-22
1-500-329-21
1-500-329-21
1-500-329-21
1-500-329-21
FERRITE BEAD INDUCTOR CHIP
FERRITE BEAD INDUCTOR CHIP
FERRITE BEAD INDUCTOR CHIP
FERRITE BEAD INDUCTOR CHIP
FERRITE BEAD INDUCTOR CHIP
FB807
1-500-329-21 FERRITE BEAD INDUCTOR CHIP
DSO
Ref. No.
Part No.
Description
FB808
FB809
FB811
FB812
1-500-329-21
1-414-760-21
1-414-760-21
1-500-329-21
FERRITE BEAD INDUCTOR CHIP
FERRITE BEAD INDUCTOR CHIP
FERRITE BEAD INDUCTOR CHIP
FERRITE BEAD INDUCTOR CHIP
Remark
FB813
FB814
FB815
FB818
FB819
1-500-329-21
1-414-760-21
1-414-235-22
1-414-760-21
1-414-760-21
FERRITE BEAD INDUCTOR CHIP
FERRITE BEAD INDUCTOR CHIP
FERRITE BEAD INDUCTOR CHIP
FERRITE BEAD INDUCTOR CHIP
FERRITE BEAD INDUCTOR CHIP
Ref. No.
KEY
Part No.
Description
R838
R839
R840
R841
R842
1-216-841-11
1-216-831-11
1-216-841-11
1-216-841-11
1-216-831-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
6.8K
47K
47K
6.8K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
Remark
R843
R844
R845
R846
R847
1-216-833-11
1-216-841-11
1-216-831-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
47K
6.8K
10K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R848
R849
R850
R851
R852
1-216-841-11
1-216-831-11
1-216-833-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
6.8K
10K
10K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R853
R854
R855
R856
R857
1-216-833-11
1-216-833-11
1-216-833-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10K
10K
10K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R858
R859
R860
R861
R862
1-216-833-11
1-216-833-11
1-216-833-11
1-216-833-11
1-216-797-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10K
10K
10K
10
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R863
R864
R865
R868
R870
1-216-797-11
1-216-797-11
1-216-864-11
1-216-864-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10
10
0
0
1K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R874
R875
R876
R877
R878
1-216-828-11
1-216-828-11
1-216-828-11
1-216-828-11
1-216-828-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
3.9K
3.9K
3.9K
3.9K
3.9K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R879
R880
R881
R894
R895
1-216-828-11
1-216-833-11
1-216-833-11
1-216-821-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
3.9K
10K
10K
1K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R899
1-216-864-11 METAL CHIP
0
5%
1/16W
< IC >
IC801
IC802
IC803
IC805
IC806
8-759-710-88
8-759-431-14
8-759-524-05
8-752-402-48
8-759-058-58
IC
IC
IC
IC
IC
NJM431U-TE2
PQ3DZ53U
TC74VHC126FT (EL)
CXD2726Q-4
TC7S04FU (TE85R)
IC807
IC808
IC809
8-759-711-82 IC NJM4580E (T1)
8-759-711-82 IC NJM4580E (T1)
8-759-711-82 IC NJM4580E (T1)
< COIL >
L801
L802
1-412-058-11 INDUCTOR CHIP 10uH
1-412-060-11 INDUCTOR CHIP 22uH
< TRANSISTOR >
Q801
8-729-920-85 TRANSISTOR
2SD1664-T101-QR
< RESISTOR >
R801
R802
R803
R804
R805
1-216-864-11
1-216-308-00
1-216-809-11
1-219-274-11
1-216-813-11
METAL CHIP
METAL CHIP
METAL CHIP
RES, CHIP
METAL CHIP
0
4.7
100
220
220
5%
5%
5%
2%
5%
1/16W
1/10W
1/16W
1/16W
1/16W
R806
R807
R811
R812
R813
1-219-286-11
1-216-864-11
1-216-861-11
1-216-859-11
1-216-864-11
RES, CHIP
METAL CHIP
METAL CHIP
RES, CHIP
METAL CHIP
680
0
2.2M
1.5M
0
2%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R815
R816
R817
R818
R819
1-216-845-11
1-216-821-11
1-216-821-11
1-216-821-11
1-216-864-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
1K
1K
1K
0
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R820
R822
R823
R824
R825
1-216-821-11
1-216-809-11
1-216-821-11
1-216-845-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
100
1K
100K
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R826
R827
R828
R829
R830
1-216-864-11
1-216-809-11
1-216-805-11
1-216-805-11
1-216-864-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
100
47
47
0
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R832
R833
R834
R835
R837
1-216-821-11
1-216-809-11
1-216-839-11
1-216-843-11
1-216-831-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
100
33K
68K
6.8K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
< VIBRATOR >
X801
1-767-467-11 VIBRATOR, CRYSTAL (16.9344MHz)
**************************************************************
KEY BOARD
**********
1-694-660-1
3-040-992-0
3-040-993-0
3-040-997-0
3-041-371-1
*
*
*
*
CONDUCTIVE BOARD, CONNECTION
HOLDER (LCD)
PLATE (LCD), LIGHT GUIDE
PLATE (LCD), GROUND
SHEET (REFLECTOR)
< CAPACITOR >
C951
C952
C953
1-164-004-11 CERAMIC CHIP
1-163-037-11 CERAMIC CHIP
1-163-137-00 CERAMIC CHIP
0.1uF
0.022uF
680PF
10%
10%
5%
25V
25V
50V
21
KEY
Ref. No.
Part No.
Description
Remark
C956
C960
1-164-489-11 CERAMIC CHIP
1-163-037-11 CERAMIC CHIP
0.22uF
0.022uF
10%
10%
16V
25V
C961
C962
C963
1-164-004-11 CERAMIC CHIP
1-164-004-11 CERAMIC CHIP
1-164-004-11 CERAMIC CHIP
0.1uF
0.1uF
0.1uF
10%
10%
10%
25V
25V
25V
< CONNECTOR >
CN901
1-794-065-21 PLUG, CONNECTOR 14P
< DIODE >
D901
D902
D903
D904
D951
8-719-423-32
8-719-422-64
8-719-422-64
8-719-422-64
8-719-420-90
DIODE
DIODE
DIODE
DIODE
DIODE
MA8120-M-TX
MA8062-M-TX
MA8062-M-TX
MA8062-M-TX
MA8051-M-TX
D952
D954
8-719-422-64 DIODE MA8062-M-TX
8-719-422-89 DIODE MA8082-H-TX
< IC >
IC901
IC951
8-759-653-26 IC LC75878W
8-749-012-25 IC RS-170-TU
< LIQUID CRYSTAL DISPLAY >
LCD901 1-803-915-11 DISPLAY PANEL, LIQUID CRYSTAL (C8500R)
LCD901 1-803-915-21 DISPLAY PANEL, LIQUID CRYSTAL (C8500X)
< LED >
LED901 8-719-026-38 LED CL-150SR-CD-T (ILLUMINATION)
(C8500X)
LED901 8-719-064-68 LED LBT676-J2/K1/K2 (ILLUMINATION)
(C8500R)
LED902 8-719-026-38 LED CL-150SR-CD-T (ILLUMINATION)
(C8500X)
LED902 8-719-064-68 LED LBT676-J2/K1/K2 (ILLUMINATION)
(C8500R)
LED903 8-719-026-38 LED CL-150SR-CD-T (ILLUMINATION)
(C8500X)
LED903 8-719-064-68 LED LBT676-J2/K1/K2 (ILLUMINATION)
(C8500R)
LED904 8-719-026-38 LED CL-150SR-CD-T (ILLUMINATION)
(C8500X)
LED904 8-719-064-68 LED LBT676-J2/K1/K2 (ILLUMINATION)
(C8500R)
LED910 8-719-078-19 LED LWA673-R1S2*1 (LCD BACK LIGHT)
LED911 8-719-078-19 LED LWA673-R1S2*1 (LCD BACK LIGHT)
Ref. No.
Part No.
LSW901 1-771-610-11 SWITCH, TACTILE (WITH LED) (OFF) (C8500R)
LSW901 1-771-883-11 SWITCH, TACTILE (WITH LED) (OFF) (C8500X)
LSW902 1-762-620-21 SWITCH, KEY BOARD (WITH LED) (SOURCE)
(C8500R)
LSW902 1-771-476-11 SWITCH, KEY BOARD (WITH LED) (SOURCE)
(C8500X)
LSW903 1-762-620-21 SWITCH, KEY BOARD (WITH LED)
(SOUND EQ) (C8500R)
22
Remark
LSW906 1-762-620-21 SWITCH, KEY BOARD (WITH LED) (LIST)
(C8500R)
LSW906 1-771-476-11 SWITCH, KEY BOARD (WITH LED) (LIST)
(C8500X)
LSW907 1-762-620-21 SWITCH, KEY BOARD (WITH LED) (ENTER)
(C8500R)
LSW907 1-771-476-11 SWITCH, KEY BOARD (WITH LED) (ENTER)
(C8500X)
LSW908 1-771-610-11 SWITCH, TACTILE (WITH LED) (MODE)
(C8500R)
LSW908 1-771-883-11 SWITCH, TACTILE (WITH LED) (MODE)
(C8500X)
LSW909 1-762-737-11 SWITCH, KEYBOARD (LED) (DSO)
LSW910 1-762-620-21 SWITCH, KEY BOARD (WITH LED) (TA)
(C8500R)
LSW911 1-762-620-21 SWITCH, KEY BOARD (WITH LED) (AF)
(C8500R)
LSW912 1-771-610-11 SWITCH, TACTILE (WITH LED) (6) (C8500R)
LSW912
LSW913
LSW913
LSW914
LSW914
1-771-883-11
1-771-610-11
1-771-883-11
1-771-610-11
1-771-883-11
SWITCH, TACTILE (WITH LED) (6) (C8500X)
SWITCH, TACTILE (WITH LED) (5) (C8500R)
SWITCH, TACTILE (WITH LED) (5) (C8500X)
SWITCH, TACTILE (WITH LED) (4) (C8500R)
SWITCH, TACTILE (WITH LED) (4) (C8500X)
LSW915 1-771-610-11 SWITCH, TACTILE (WITH LED) (3) (C8500R)
LSW915 1-771-883-11 SWITCH, TACTILE (WITH LED) (3) (C8500X)
LSW916 1-771-610-11 SWITCH, TACTILE (WITH LED) (SHUF 2)
(C8500R)
LSW916 1-771-883-11 SWITCH, TACTILE (WITH LED) (SHUF 2)
(C8500X)
LSW917 1-771-610-11 SWITCH, TACTILE (WITH LED) (REP 1)
(C8500R)
LSW917 1-771-883-11 SWITCH, TACTILE (WITH LED) (REP 1)
(C8500X)
< TRANSISTOR >
Q901
Q902
Q903
8-729-904-75 TRANSISTOR
8-729-904-75 TRANSISTOR
8-729-904-75 TRANSISTOR
LED912 8-719-078-19 LED LWA673-R1S2*1 (LCD BACK LIGHT)
LED913 8-719-078-19 LED LWA673-R1S2*1 (LCD BACK LIGHT)
< SWITCH >
Description
LSW903 1-771-476-11 SWITCH, KEY BOARD (WITH LED)
(SOUND EQ) (C8500X)
LSW904 1-762-620-21 SWITCH, KEY BOARD (WITH LED) (MENU)
(C8500R)
LSW904 1-771-476-11 SWITCH, KEY BOARD (WITH LED) (MENU)
(C8500X)
LSW905 1-762-620-21 SWITCH, KEY BOARD (WITH LED)
(PTY, DSPL) (C8500R)
LSW905 1-771-476-11 SWITCH, KEY BOARD (WITH LED) (DSPL)
(C8500X)
DTD114EK-T-146 (C8500R)
DTD114EK-T-146 (C8500R)
DTD114EK-T-146
< RESISTOR >
R901
R902
R903
R904
R905
1-216-647-11
1-216-647-11
1-216-647-11
1-216-651-11
1-216-655-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
680
680
680
1K
1.5K
0.5%
0.5%
0.5%
0.5%
0.5%
1/10W
1/10W
1/10W
1/10W
1/10W
R906
R907
R908
R909
R910
1-216-655-11
1-216-659-11
1-216-663-11
1-216-667-11
1-216-671-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1.5K
2.2K
3.3K
4.7K
6.8K
0.5%
0.5%
0.5%
0.5%
0.5%
1/10W
1/10W
1/10W
1/10W
1/10W
KEY
Ref. No.
Part No.
Description
R911
R912
R913
R914
R915
1-208-806-11
1-216-647-11
1-216-647-11
1-216-647-11
1-216-651-11
RES, CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
680
680
680
1K
2%
0.5%
0.5%
0.5%
0.5%
1/10W
1/10W
1/10W
1/10W
1/10W
Remark
R916
R917
R918
R919
R920
1-216-655-11
1-216-655-11
1-216-659-11
1-216-663-11
1-216-667-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1.5K
1.5K
2.2K
3.3K
4.7K
0.5%
0.5%
0.5%
0.5%
0.5%
1/10W
1/10W
1/10W
1/10W
1/10W
R921
1-216-810-11 METAL CHIP
120
5%
R921
1-216-811-11 METAL CHIP
150
5%
R922
1-216-807-11 METAL CHIP
68
5%
R923
1-216-811-11 METAL CHIP
150
5%
R923
1-216-812-11 METAL CHIP
180
5%
Ref. No.
R924
1-216-807-11 METAL CHIP
68
5%
R925
1-216-811-11 METAL CHIP
150
5%
R925
1-216-812-11 METAL CHIP
180
5%
R926
1-216-807-11 METAL CHIP
68
5%
R927
1-216-029-00 METAL CHIP
150
5%
R927
1-216-037-00 METAL CHIP
330
5%
R928
1-216-021-00 METAL CHIP
68
5%
R929
1-216-033-00 METAL CHIP
220
5%
R931
R932
1-216-813-11 METAL CHIP
1-216-813-11 METAL CHIP
220
220
5%
5%
R933
1-216-813-11 METAL CHIP
220
5%
R934
1-216-813-11 METAL CHIP
220
5%
R938
R939
1-216-809-11 METAL CHIP
1-216-813-11 METAL CHIP
100
220
5%
5%
R940
1-216-821-11 METAL CHIP
1K
5%
R951
R952
R953
R954
R955
1-216-819-11
1-216-825-11
1-216-857-11
1-216-821-11
1-216-049-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
RES, CHIP
680
2.2K
1M
1K
1K
5%
5%
5%
5%
5%
R956
R957
R958
R960
R961
1-216-049-11
1-216-841-11
1-216-037-00
1-216-041-00
1-216-829-11
RES, CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
47K
330
470
4.7K
R962
R963
R964
R970
1-216-829-11
1-216-829-11
1-216-829-11
1-216-815-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
4.7K
4.7K
330
1/16W
(C8500R)
1/16W
(C8500R)
1/16W
(C8500X)
1/16W
(C8500R)
1/10W
(C8500R)
Description
Remark
R972
1-216-041-00 METAL CHIP
470
5%
1/10W
R973
R975
R977
R978
R999
1-216-815-11
1-216-864-11
1-216-815-11
1-216-815-11
1-216-864-11
330
0
330
330
0
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
(C8500X)
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
< ROTARY ENCODER >
RE901
1/16W
(C8500X)
1/16W
(C8500R)
1/16W
(C8500R)
1/16W
(C8500R)
1/16W
(C8500X)
Part No.
MAIN
1-475-014-11 ENCODER, ROTARY (VOLUME CONTROL)
< SWITCH >
S901
1-771-884-11 SWITCH, TACTILEILE (SEEK/AMS - . m)
S902
1-771-884-11 SWITCH, TACTILEILE (DISC +, PRST +)
S903
1-771-884-11 SWITCH, TACTILEILE (SEEK/AMS + > M)
S904
1-771-884-11 SWITCH, TACTILEILE (DISC -, PRST -)
**************************************************************
*
*
*
*
A-3294-906-A
A-3294-915-A
A-3294-918-A
A-3294-919-A
MAIN BOARD, COMPLETE (C8500X)
MAIN BOARD, COMPLETE (C8500R: TYPE A)
MAIN BOARD, COMPLETE (C8500R: TYPE B)
MAIN BOARD, COMPLETE (C8500R: TYPE C)
**********************
*
*
*
*
3-040-996-32
3-040-996-72
3-040-998-01
3-041-261-01
7-685-793-09
HEAT SINK (2P) (C8500R)
HEAT SINK (2P) (C8500X)
BRACKET (IC)
BRACKET (TR)
SCREW +PTT 2.6X8 (S)
7-685-795-09 SCREW +PTT 2.6X12 (S)
1/10W
(C8500X)
1/10W
(C8500R)
1/10W
(C8500X)
1/16W
1/16W
< BUZZER >
BZ101
1-504-920-11 BUZZER
< CAPACITOR >
C101
C103
C104
C105
C106
1-107-826-11
1-107-725-11
1-162-923-11
1-131-661-21
1-126-176-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
ELECT
0.1uF
0.1uF
47PF
100uF
220uF
10%
10%
5%
20%
20%
16V
16V
50V
10V
10V
C107
C108
C109
C110
C111
1-107-826-11
1-107-826-11
1-162-970-11
1-117-681-11
1-163-021-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.01uF
100uF
0.01uF
10%
10%
10%
20%
10%
16V
16V
25V
16V
50V
1/16W
1/16W
1/16W
1/16W
1/10W
C112
C113
C114
C115
C116
1-164-816-11
1-117-681-11
1-124-584-00
1-163-031-11
1-162-970-11
CERAMIC CHIP
ELECT CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
220PF
100uF
100uF
0.01uF
0.01uF
2%
20%
20%
50V
16V
10V
50V
25V
5%
5%
5%
5%
5%
1/10W
1/16W
1/10W
1/10W
1/16W
C117
C118
C119
C120
C121
1-124-584-00
1-126-926-11
1-125-701-11
1-164-360-11
1-104-942-11
ELECT
ELECT
DOUBLE LAYER
CERAMIC CHIP
ELECT
100uF
1000uF
0.047F
0.1uF
1uF
20%
20%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
C122
C123
C124
C126
1-164-156-11
1-164-360-11
1-164-156-11
1-163-009-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.001uF
1/16W
(C8500R)
1/16W
(C8500R)
1/16W
1/16W
(C8500X)
1/16W
(C8500X)
10%
20%
10V
10V
5.5V
16V
50V
10%
25V
16V
25V
50V
23
MAIN
Ref. No.
Part No.
Description
Remark
C127
1-163-009-11 CERAMIC CHIP
0.001uF
C129
C130
C201
1-163-038-11 CERAMIC CHIP
1-163-038-11 CERAMIC CHIP
1-164-156-11 CERAMIC CHIP
0.1uF
0.1uF
0.1uF
C202
1-162-962-11 CERAMIC CHIP
470PF
10%
C203
1-164-739-11 CERAMIC CHIP
560PF
5%
C204
1-164-505-11 CERAMIC CHIP
2.2uF
C205
1-162-920-11 CERAMIC CHIP
27PF
5%
C206
1-162-920-11 CERAMIC CHIP
27PF
5%
C207
1-164-156-11 CERAMIC CHIP
0.1uF
C208
1-164-156-11 CERAMIC CHIP
0.1uF
C209
1-163-263-11 CERAMIC CHIP
330PF
C210
1-162-966-11 CERAMIC CHIP
0.0022uF 10%
C211
1-162-927-11 CERAMIC CHIP
100PF
5%
C214
1-162-970-11 CERAMIC CHIP
0.01uF
10%
C215
C219
C220
C221
1-163-021-11
1-163-231-11
1-126-157-11
1-124-589-11
0.01uF
15PF
10uF
47uF
10%
5%
20%
20%
C223
1-164-227-11 CERAMIC CHIP
0.022uF
10%
C224
C225
1-126-157-11 ELECT
1-163-031-11 CERAMIC CHIP
10uF
0.01uF
20%
C226
C227
C229
1-124-589-11 ELECT
1-127-573-11 CERAMIC CHIP
1-164-156-11 CERAMIC CHIP
47uF
1uF
0.1uF
20%
10%
C230
C231
C232
1-124-589-11 ELECT
1-107-826-11 CERAMIC CHIP
1-162-964-11 CERAMIC CHIP
47uF
0.1uF
0.001uF
20%
10%
10%
C233
1-163-038-11 CERAMIC CHIP
0.1uF
C234
1-164-489-11 CERAMIC CHIP
0.22uF
10%
C235
1-162-964-11 CERAMIC CHIP
0.001uF
10%
C236
1-163-038-11 CERAMIC CHIP
0.1uF
C238
1-162-964-11 CERAMIC CHIP
0.001uF
C239
1-162-915-11 CERAMIC CHIP
10PF
C240
1-164-005-11 CERAMIC CHIP
0.47uF
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
10%
5%
1-164-315-11 CERAMIC CHIP
470PF
5%
C242
1-163-809-11 CERAMIC CHIP
0.047uF
10%
C245
1-107-725-11 CERAMIC CHIP
0.1uF
10%
Ref. No.
Part No.
Description
Remark
C246
C301
1-163-038-11 CERAMIC CHIP
1-164-346-11 CERAMIC CHIP
0.1uF
1uF
C302
C303
C304
C305
C306
1-127-573-11
1-162-964-11
1-127-573-11
1-164-227-11
1-162-968-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
1uF
0.001uF
1uF
0.022uF
0.0047uF
10%
10%
10%
10%
10%
16V
50V
16V
25V
50V
C307
C308
C309
C311
C312
1-162-970-11
1-107-823-11
1-164-346-11
1-125-838-11
1-107-725-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.47uF
1uF
2.2uF
0.1uF
10%
10%
10%
10%
25V
16V
16V
6.3V
16V
C313
C314
C315
C316
C317
1-162-923-11
1-125-838-11
1-124-589-11
1-127-573-11
1-127-573-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
47PF
2.2uF
47uF
1uF
1uF
5%
10%
20%
10%
10%
50V
6.3V
16V
16V
16V
C318
C319
C320
C321
1-127-573-11
1-127-573-11
1-127-573-11
1-127-573-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
1uF
1uF
1uF
1uF
10%
10%
10%
10%
C322
1-127-573-11 CERAMIC CHIP
1uF
10%
C323
1-127-573-11 CERAMIC CHIP
1uF
10%
C324
1-127-573-11 CERAMIC CHIP
1uF
10%
C325
1-127-573-11 CERAMIC CHIP
1uF
10%
C326
1-127-573-11 CERAMIC CHIP
1uF
10%
16V
50V
(C8500X)
16V
16V
25V
C327
1-124-589-11 ELECT
47uF
20%
C328
1-124-589-11 ELECT
47uF
20%
C329
1-124-589-11 ELECT
47uF
20%
16V
16V
50V
(C8500R)
25V
(C8500R)
16V
C330
1-124-584-00 ELECT
100uF
20%
C331
1-124-584-00 ELECT
100uF
20%
C332
1-124-584-00 ELECT
100uF
20%
C333
1-124-584-00 ELECT
100uF
20%
C334
1-124-584-00 ELECT
100uF
20%
C335
1-124-584-00 ELECT
100uF
20%
C336
C337
1-107-725-11 CERAMIC CHIP
1-163-235-11 CERAMIC CHIP
0.1uF
22PF
10%
5%
C338
1-163-235-11 CERAMIC CHIP
22PF
5%
C339
1-163-235-11 CERAMIC CHIP
22PF
5%
C340
1-163-235-11 CERAMIC CHIP
22PF
5%
C341
1-163-235-11 CERAMIC CHIP
22PF
5%
25V
25V
25V
(C8500R)
50V
(C8500R)
50V
(C8500R)
16V
(C8500R)
50V
(C8500R)
50V
(C8500R)
25V
(C8500R)
25V
(C8500R)
50V
(C8500R)
50V
(C8500R)
50V
(C8500R)
25V
50V
50V
16V
16V
(C8500R)
25V
50V
(C8500R)
25V
(C8500R)
10%
50V
(C8500R)
0.5PF 50V
(C8500R)
25V
(C8500R)
C241
24
50V
50V
(C8500R)
25V
(C8500R)
16V
(C8500R)
25V
16V
16V
16V
16V
16V
(C8500X)
16V
(C8500X)
16V
(C8500X)
16V
(C8500X)
16V
(C8500X)
16V
(C8500X)
16V
(C8500X)
16V
(C8500X)
16V
(C8500X)
10V
(C8500X)
10V
(C8500X)
10V
(C8500X)
10V
(C8500X)
10V
(C8500X)
10V
(C8500X)
16V
50V
(C8500X)
50V
(C8500X)
50V
(C8500X)
50V
(C8500X)
50V
(C8500X)
MAIN
Ref. No.
Part No.
Description
Part No.
Description
C386
C387
C399
C401
C402
1-163-031-11
1-163-031-11
1-163-251-11
1-164-360-11
1-124-589-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
0.01uF
0.01uF
100PF
0.1uF
47uF
C403
C405
C406
C407
C408
1-127-573-11
1-162-970-11
1-131-661-21
1-163-038-11
1-128-057-11
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
ELECT
1uF
0.01uF
100uF
0.1uF
330uF
10%
10%
20%
C409
C410
C501
C502
1-128-057-11
1-135-474-21
1-164-360-11
1-104-760-11
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
330uF
330uF
0.1uF
0.047uF
20%
20%
C502
1-163-017-00 CERAMIC CHIP
0.0047uF 5%
C504
C505
C506
C507
C508
1-163-038-11
1-163-038-11
1-164-360-11
1-164-315-11
1-164-816-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
470PF
220PF
C509
C510
C511
C512
C513
1-163-234-11
1-163-237-11
1-162-964-11
1-107-725-11
1-163-038-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
20PF
27PF
0.001uF
0.1uF
0.1uF
5%
5%
10%
10%
50V
50V
50V
16V
25V
C514
C515
C516
C517
C518
1-163-237-11
1-163-237-11
1-164-156-11
1-107-823-11
1-107-725-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
27PF
27PF
0.1uF
0.47uF
0.1uF
5%
5%
50V
50V
25V
16V
16V
50V
50V
50V
50V
50V
C520
C601
C602
C603
C604
1-163-009-11
1-163-038-11
1-124-229-00
1-163-021-11
1-107-725-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
0.001uF
0.1uF
33uF
0.01uF
0.1uF
10%
20%
10%
10%
50V
25V
10V
50V
16V
16V
16V
16V
(C8500X)
16V
(C8500X)
16V
(C8500X)
C605
C606
C607
C701
C702
1-163-021-11
1-162-970-11
1-163-009-11
1-162-970-11
1-104-942-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
0.01uF
0.01uF
0.001uF
0.01uF
1uF
10%
10%
10%
10%
20%
50V
25V
50V
25V
50V
C703
C704
C705
C706
C707
1-163-038-11
1-163-038-11
1-163-038-11
1-107-826-11
1-162-974-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.1uF
0.01uF
C708
C709
C710
C711
C712
1-163-031-11
1-126-154-11
1-163-038-11
1-107-725-11
1-163-038-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
47uF
0.1uF
0.1uF
0.1uF
C713
C714
C715
C751
C752
1-163-038-11
1-162-970-11
1-162-970-11
1-162-970-11
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.01uF
0.01uF
0.01uF
0.01uF
10%
10%
10%
10%
25V
25V
25V
25V
25V
C753
1-162-927-11 CERAMIC CHIP
100PF
5%
50V
Remark
C342
1-163-235-11 CERAMIC CHIP
22PF
5%
50V
(C8500X)
C343
C344
C345
C346
C347
1-126-157-11
1-126-157-11
1-126-157-11
1-126-157-11
1-164-506-11
ELECT
ELECT
ELECT
ELECT
CERAMIC CHIP
10uF
10uF
10uF
10uF
4.7uF
20%
20%
20%
20%
16V
16V
16V
16V
16V
C348
C349
C350
C351
C352
1-164-506-11
1-164-489-11
1-164-489-11
1-164-489-11
1-164-489-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
4.7uF
0.22uF
0.22uF
0.22uF
0.22uF
10%
10%
10%
10%
C353
1-127-573-11 CERAMIC CHIP
1uF
10%
C354
1-104-942-11 ELECT
1uF
20%
C354
1-124-259-11 ELECT
4.7uF
20%
C355
C356
1-162-919-11 CERAMIC CHIP
1-162-919-11 CERAMIC CHIP
22PF
22PF
5%
5%
C357
C358
C359
C360
C361
1-162-919-11
1-162-919-11
1-163-235-11
1-162-919-11
1-163-038-11
22PF
22PF
22PF
22PF
0.1uF
5%
5%
5%
5%
C362
1-124-261-00 ELECT
10uF
20%
C362
1-124-589-11 ELECT
47uF
20%
C363
C364
C365
1-163-009-11 CERAMIC CHIP
1-163-009-11 CERAMIC CHIP
1-107-725-11 CERAMIC CHIP
0.001uF
0.001uF
0.1uF
10%
10%
10%
C366
C367
C368
C369
C370
1-162-927-11
1-162-964-11
1-104-942-11
1-162-964-11
1-104-942-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
100PF
0.001uF
1uF
0.001uF
1uF
5%
10%
20%
10%
20%
C371
C372
C373
1-135-473-21 ELECT
1-107-725-11 CERAMIC CHIP
1-107-826-11 CERAMIC CHIP
3300uF
0.1uF
0.1uF
20%
10%
10%
C374
1-107-826-11 CERAMIC CHIP
0.1uF
10%
C375
1-107-826-11 CERAMIC CHIP
0.1uF
10%
C376
1-107-826-11 CERAMIC CHIP
0.1uF
10%
C377
1-107-826-11 CERAMIC CHIP
0.1uF
10%
C378
1-107-826-11 CERAMIC CHIP
0.1uF
10%
C379
C380
1-127-573-11 CERAMIC CHIP
1-127-573-11 CERAMIC CHIP
1uF
1uF
10%
10%
C381
C382
C383
C384
C385
1-163-038-11
1-163-038-11
1-163-038-11
1-163-031-11
1-163-031-11
0.1uF
0.1uF
0.1uF
0.01uF
0.01uF
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
16V
16V
16V
16V
16V
16V
(C8500X)
50V
(C8500X)
16V
(C8500R)
50V
50V
50V
50V
50V
50V
25V
50V
(C8500R)
16V
(C8500X)
50V
50V
16V
16V
(C8500X)
16V
(C8500X)
16V
(C8500X)
16V
16V
(C8500X)
25V
25V
25V
50V
50V
Ref. No.
Remark
5%
20%
20%
10%
5%
2%
10%
10%
10%
20%
10%
50V
50V
50V
16V
16V
16V
25V
10V
25V
6.3V
6.3V
6.3V
16V
50V
(C8500X)
50V
(C8500R)
25V
25V
16V
50V
50V
25V
25V
25V
16V
50V
50V
6.3V
25V
16V
25V
25
MAIN
Ref. No.
Part No.
Description
C755
C756
C757
C759
1-162-927-11
1-162-927-11
1-162-927-11
1-162-927-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100PF
100PF
100PF
100PF
5%
5%
5%
5%
50V
50V
50V
50V
Remark
C901
C902
1-162-970-11 CERAMIC CHIP
1-104-942-11 ELECT
0.01uF
1uF
10%
20%
25V
50V
< CONNECTOR/JACK >
CN101
CN102
* CN301
CN302
1-774-701-11
1-764-808-21
1-564-506-11
1-774-700-11
CN401
PIN, CONNECTOR 16P
JACK (ANT) (FM/AM ANTENNA)
PLUG, CONNECTOR 3P
JACK, PIN 6P
(BUS AUDIO IN, AUDIO OUT REAR/FRONT)
1-764-617-12 PIN, CONNECTOR (PC BOARD) 30P
CN601
CN701
1-580-907-31 PLUG, CONNECTOR (BUS CONTROL IN)
1-770-408-11 CONNECTOR, BOARD TO BOARD 14P
< DIODE >
D101
D102
D103
D104
D105
8-719-420-51
8-719-422-29
8-719-060-81
8-719-801-78
8-719-420-14
DIODE
DIODE
DIODE
DIODE
DIODE
MA729-TX
MA8047-L-TX
MA735-TX
MA152WK-TX
MA8082-M (TX)
D106
D107
D108
D109
D201
8-719-060-81
8-719-422-62
8-719-422-86
8-719-977-12
8-719-422-41
DIODE
DIODE
DIODE
DIODE
DIODE
MA735-TX
MA8062-L-TX
MA8082-L-TX
MA8068-M-TX
MA8051-L-TX
D203
D204
D205
D301
D302
8-719-800-76
8-719-420-90
8-719-073-01
8-719-105-99
8-719-073-01
DIODE
DIODE
DIODE
DIODE
DIODE
MA153-TX (C8500R)
MA8051-M-TX (C8500R)
MA111-TX
RD6.2M-B1
MA111-TX
D352
D353
D354
D355
D355
8-719-422-89
8-719-801-78
8-719-801-78
8-719-079-66
8-719-200-82
DIODE
DIODE
DIODE
DIODE
DIODE
MA8082-H-TX
MA152WK-TX
MA152WK-TX
1ZB22 (TP5.SONY) (C8500R)
11ES2-TB5 (C8500X)
D356
D356
D357
D357
D358
8-719-079-66
8-719-200-82
8-719-079-66
8-719-200-82
8-719-079-66
DIODE
DIODE
DIODE
DIODE
DIODE
1ZB22 (TP5.SONY) (C8500R)
11ES2-TB5 (C8500X)
1ZB22 (TP5.SONY) (C8500R)
11ES2-TB5 (C8500X)
1ZB22 (TP5.SONY) (C8500R)
D358
D359
D359
D360
D360
8-719-200-82
8-719-079-66
8-719-200-82
8-719-079-66
8-719-200-82
DIODE
DIODE
DIODE
DIODE
DIODE
11ES2-TB5 (C8500X)
1ZB22 (TP5.SONY) (C8500R)
11ES2-TB5 (C8500X)
1ZB22 (TP5.SONY) (C8500R)
11ES2-TB5 (C8500X)
D361
D361
D362
D362
D363
8-719-079-66
8-719-200-82
8-719-079-66
8-719-200-82
8-719-049-38
DIODE
DIODE
DIODE
DIODE
DIODE
1ZB22 (TP5.SONY) (C8500R)
11ES2-TB5 (C8500X)
1ZB22 (TP5.SONY) (C8500R)
11ES2-TB5 (C8500X)
1N5404TU
D501
D502
D601
D602
D603
8-719-420-90
8-719-073-01
8-719-073-01
8-719-073-01
8-719-057-80
DIODE
DIODE
DIODE
DIODE
DIODE
MA8051-M-TX (C8500R)
MA111-TX
MA111-TX
MA111-TX
MA8180-M-TX
26
Ref. No.
Part No.
Description
D604
D604
D605
D606
D606
8-719-057-80
8-719-071-25
8-719-073-01
8-719-057-80
8-719-071-25
DIODE
DIODE
DIODE
DIODE
DIODE
MA8180-M-TX (C8500R)
HZU18B2TRF (C8500X)
MA111-TX
MA8180-M-TX (C8500R)
HZU18B2TRF (C8500X)
D607
D608
D609
D610
D611
8-719-977-12
8-719-420-51
8-719-057-80
8-719-073-01
8-719-073-01
DIODE
DIODE
DIODE
DIODE
DIODE
MA8068-M-TX
MA729-TX
MA8180-M-TX
MA111-TX
MA111-TX
D612
D612
D613
D613
D614
8-719-064-08
8-719-977-12
8-719-064-08
8-719-977-12
8-719-073-01
DIODE
DIODE
DIODE
DIODE
DIODE
HZU6.8B2TRF (C8500X)
MA8068-M-TX (C8500R)
HZU6.8B2TRF (C8500X)
MA8068-M-TX (C8500R)
MA111-TX
D701
D702
D703
D751
D752
8-719-400-20
8-719-073-01
8-719-801-78
8-719-423-32
8-719-422-64
DIODE
DIODE
DIODE
DIODE
DIODE
MA152WA-TX
MA111-TX
MA152WK-TX
MA8120-M-TX
MA8062-M-TX
D753
D754
D755
D756
D757
8-719-105-99 DIODE
8-719-423-32 DIODE
8-719-423-32 DIODE
8-719-4105-99 DIODE
8-719-105-99 DIODE
RD6.2M-B1
MA8120-M-TX
MA8120-M-TX
RD6.2M-B1
RD6.2M-B1
D758
D759
D760
D761
D762
8-719-423-32
8-719-105-99
8-719-105-99
8-719-423-32
8-719-423-32
MA8120-M-TX
RD6.2M-B1
RD6.2M-B1
MA8120-M-TX
MA8120-M-TX
DIODE
DIODE
DIODE
DIODE
DIODE
Remark
< FERRITE BEAD >
FB201
1-500-245-11 FERRITE BEAD INDUCTOR CHIP (C8500R)
< IC >
IC201
IC202
IC301
IC302
IC303
8-759-492-59
8-759-711-82
8-759-653-27
8-759-521-35
8-759-593-97
IC
IC
IC
IC
IC
SAA6588T/V2-118 (C8500R)
NJM4580E (T1) (C8500R)
TDA7402TR
TL5001CDR
NJM2160AM-TE2 (C8500X)
IC304
IC305
IC351
IC351
IC502
8-759-593-97
8-759-593-97
8-759-660-96
8-759-663-88
8-759-670-67
IC
IC
IC
IC
IC
NJM2160AM-TE2 (C8500X)
NJM2160AM-TE2 (C8500X)
TDA7560 (C8500X)
TA8268H (C8500R)
MB90574BPMT-G-264-BND (C8500R)
IC502
IC503
IC504
IC601
IC701
8-759-686-86
8-759-581-75
8-759-495-76
8-759-449-89
8-759-686-87
IC
IC
IC
IC
IC
MB90574BPMT-G-290-BND (C8500X)
XC61AN4102MR
RN5VD33AA-TL
BA8270F-E2
HD643255A25F
IC702
8-759-277-63 IC TC7W14FU (TE12R)
< JACK >
J651
1-566-822-41 JACK (REMOTE IN)
< COIL >
L101
1-469-673-21 INDUCTOR
100uH
MAIN
Ref. No.
Part No.
Description
L102
L103
L104
L201
1-469-674-21
1-469-675-21
1-414-185-51
1-414-185-51
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
220uH
100uH
22uH
22uH
Remark
L301
L351
L402
L701
1-414-179-51
1-419-476-11
1-469-673-21
1-414-856-51
INDUCTOR
COIL, CHOKE
INDUCTOR
INDUCTOR
2.2uH
250uH
100uH
10uH
< TRANSISTOR >
Q101
Q102
Q103
Q104
Q105
8-729-421-19
8-729-120-28
8-729-026-49
8-729-019-03
8-729-019-03
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
UN2213-TX
2SC2412K-T-146-R
2SA1037AK-T146-R
2SB1202FA-T-TL
2SB1202FA-T-TL
Q106
Q107
Q108
Q109
Q110
8-729-120-28
8-729-019-03
8-729-120-28
8-729-120-28
8-729-040-17
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC2412K-T-146-R
2SB1202FA-T-TL
2SC2412K-T-146-R
2SC2412K-T-146-R
2SD2164-K
Q111
Q112
Q113
Q201
Q203
8-729-120-28
8-729-120-28
8-729-120-28
8-729-920-85
8-729-106-60
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC2412K-T-146-R
2SC2412K-T-146-R
2SC2412K-T-146-R
2SD1664-T101-QR
2SB1132-T101-QR
Q204
Q208
Q209
Q351
Q352
8-729-421-22
8-729-421-22
8-729-120-28
8-729-421-22
8-729-120-28
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
UN2211-TX
UN2211-TX (C8500R)
2SC2412K-T-146-R
UN2211-TX
2SC2412K-T-146-R
Q353
Q354
Q355
Q356
Q357
8-729-424-59
8-729-424-18
8-729-424-59
8-729-021-95
8-729-021-95
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
UN2212-TX
UN2113-TX
UN2212-TX
RN1441-A (TE85L)
RN1441-A (TE85L)
Q358
Q359
Q360
Q361
Q363
8-729-021-95
8-729-021-95
8-729-021-95
8-729-021-95
8-729-421-22
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
RN1441-A (TE85L)
RN1441-A (TE85L)
RN1441-A (TE85L)
RN1441-A (TE85L)
UN2211-TX
Q364
Q365
Q366
Q401
Q404
8-729-421-22
8-729-821-63
8-729-821-63
8-729-019-03
8-729-120-28
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
UN2211-TX
2SB1203T-TL
2SB1203T-TL
2SB1202FA-T-TL
2SC2412K-T-146-R
Q405
Q406
Q407
Q601
Q602
8-729-120-28
8-729-019-03
8-729-421-22
8-729-120-28
8-729-120-28
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC2412K-T-146-R
2SB1202FA-T-TL
UN2211-TX
2SC2412K-T-146-R
2SC2412K-T-146-R
Q603
Q604
Q605
Q701
Q702
8-729-424-18
8-729-421-22
8-729-424-18
8-729-424-08
8-729-424-08
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
UN2113-TX
UN2211-TX
UN2113-TX
UN2111-TX
UN2111-TX
Q703
Q704
Q705
8-729-120-28 TRANSISTOR
8-729-019-03 TRANSISTOR
8-729-120-28 TRANSISTOR
2SC2412K-T-146-R
2SB1202FA-T-TL
2SC2412K-T-146-R
Ref. No.
Part No.
Description
Remark
Q901
Q902
8-729-106-60 TRANSISTOR
8-729-120-28 TRANSISTOR
2SB1132-T101-QR
2SC2412K-T-146-R
Q903
8-729-120-28 TRANSISTOR
2SC2412K-T-146-R
< RESISTOR >
R101
R102
R103
R104
R105
1-216-839-11
1-218-879-11
1-216-845-11
1-218-903-11
1-218-832-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
33K
22K
100K
220K
8.2K
5%
0.5%
5%
0.5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R106
R107
R108
R109
R110
1-216-829-11
1-216-839-11
1-216-849-11
1-216-841-11
1-216-057-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
33K
220K
47K
2.2K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/10W
R111
R112
R113
R114
R115
1-216-057-00
1-216-057-00
1-216-049-11
1-216-049-11
1-216-041-00
METAL CHIP
METAL CHIP
RES, CHIP
RES, CHIP
METAL CHIP
2.2K
2.2K
1K
1K
470
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R116
R117
R118
R119
R120
1-216-049-11
1-216-037-00
1-216-033-00
1-216-825-11
1-216-817-11
RES, CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
330
220
2.2K
470
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/16W
1/16W
R121
R122
R123
R124
R125
1-216-049-11
1-216-833-11
1-216-829-11
1-216-845-11
1-216-308-00
RES, CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
10K
4.7K
100K
4.7
5%
5%
5%
5%
5%
1/10W
1/16W
1/16W
1/16W
1/10W
R126
R127
R128
R129
R130
1-216-845-11
1-216-833-11
1-216-839-11
1-216-833-11
1-216-077-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
RES, CHIP
100K
10K
33K
10K
15K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/10W
R131
R132
R133
R134
R136
1-216-841-11
1-216-845-11
1-216-841-11
1-216-845-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
100K
47K
100K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R137
R138
R139
R140
R141
1-216-833-11
1-216-295-11
1-216-001-00
1-216-041-00
1-216-049-11
METAL CHIP
SHORT
METAL CHIP
METAL CHIP
RES, CHIP
10K
0
10
470
1K
5%
1/16W
5%
5%
5%
1/10W
1/10W
1/10W
R142
R201
1-216-049-11 RES, CHIP
1-216-853-11 METAL CHIP
1K
470K
5%
5%
R202
1-216-821-11 METAL CHIP
1K
5%
R203
1-216-832-11 METAL CHIP
8.2K
5%
R204
1-216-817-11 METAL CHIP
470
5%
1/10W
1/16W
(C8500R)
1/16W
(C8500R)
1/16W
(C8500R)
1/16W
(C8500R)
R205
R206
1-216-825-11 METAL CHIP
1-216-001-00 METAL CHIP
2.2K
10
5%
5%
R207
1-216-001-00 METAL CHIP
10
5%
1/16W
1/10W
(C8500R)
1/10W
27
MAIN
Ref. No.
Part No.
Description
Remark
R208
1-216-001-00 METAL CHIP
10
5%
R209
1-216-025-11 RES, CHIP
100
5%
R210
R211
1-216-025-11 RES, CHIP
1-216-025-11 RES, CHIP
100
100
5%
5%
R212
1-216-025-11 RES, CHIP
100
5%
R213
R214
1-216-864-11 METAL CHIP
1-216-001-00 METAL CHIP
0
10
R215
R216
R217
R218
R219
1-216-841-11
1-216-817-11
1-216-839-11
1-216-829-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
R221
Ref. No.
Part No.
Description
Remark
1/10W
(C8500R)
1/10W
R320
1-216-081-00 METAL CHIP
22K
5%
R321
1-216-081-00 METAL CHIP
22K
5%
R322
1-216-081-00 METAL CHIP
22K
5%
R323
1-216-081-00 METAL CHIP
22K
5%
R324
1-216-065-00 RES, CHIP
4.7K
5%
5%
5%
1/10W
1/10W
(C8500R)
1/10W
(C8500R)
1/16W
1/10W
R325
1-216-085-00 METAL CHIP
33K
5%
47K
470
33K
4.7K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R326
1-216-085-00 METAL CHIP
33K
5%
R327
1-216-085-00 METAL CHIP
33K
5%
R328
1-216-085-00 METAL CHIP
33K
5%
1-216-073-00 METAL CHIP
10K
5%
R329
1-216-085-00 METAL CHIP
33K
5%
R222
1-216-825-11 METAL CHIP
2.2K
5%
R330
1-216-085-00 METAL CHIP
33K
5%
R223
1-216-073-00 METAL CHIP
10K
5%
R224
1-216-829-11 METAL CHIP
4.7K
5%
R226
1-216-845-11 METAL CHIP
100K
5%
1/10W
(C8500R)
1/16W
(C8500R)
1/10W
(C8500R)
1/16W
(C8500R)
1/16W
(C8500R)
R331
R332
R333
R334
1-216-295-11
1-216-295-11
1-216-295-11
1-216-295-11
0 (C8500R)
0 (C8500R)
0 (C8500R)
0 (C8500R)
R227
1-216-825-11 METAL CHIP
2.2K
5%
R335
R336
R337
1-216-295-11 SHORT
1-216-295-11 SHORT
1-216-089-11 RES, CHIP
0 (C8500R)
0 (C8500R)
47K
5%
R228
1-216-809-11 METAL CHIP
100
5%
R230
1-216-121-11 RES, CHIP
1M
5%
R338
R339
1-216-833-11 METAL CHIP
1-216-089-11 RES, CHIP
10K
47K
5%
5%
1/10W
(C8500X)
1/16W
1/10W
R231
1-216-809-11 METAL CHIP
100
5%
R233
1-216-825-11 METAL CHIP
2.2K
5%
R234
R236
R237
R238
R301
1-216-295-11
1-216-295-11
1-216-295-11
1-216-295-11
1-216-864-11
0
0
0
0 (C8500R)
0
5%
R340
R341
R343
R344
R345
1-216-073-00
1-216-864-11
1-216-813-11
1-216-813-11
1-216-813-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
0
220
220
220
5%
5%
5%
5%
5%
1/10W
1/16W
1/16W
1/16W
1/16W
R346
R347
R348
R349
1-216-813-11
1-216-813-11
1-216-813-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
220
220
220
1K
5%
5%
5%
5%
R302
R305
1-216-025-11 RES, CHIP
1-216-809-11 METAL CHIP
100
100
5%
5%
R349
1-216-864-11 METAL CHIP
0
5%
1/16W
1/16W
1/16W
1/16W
(C8500R)
1/16W
(C8500X)
R305
1-216-817-11 METAL CHIP
470
5%
R350
1-216-073-00 METAL CHIP
10K
5%
R306
R307
1-216-841-11 METAL CHIP
1-216-809-11 METAL CHIP
47K
100
5%
5%
R350
R351
R352
R353
1-216-295-11
1-216-837-11
1-216-837-11
1-216-837-11
SHORT
METAL CHIP
METAL CHIP
METAL CHIP
0 (C8500R)
22K
5%
22K
5%
22K
5%
1/16W
1/16W
1/16W
R307
1-216-817-11 METAL CHIP
470
5%
R310
R311
R312
R313
1-216-809-11
1-216-057-00
1-216-073-00
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
2.2K
10K
100
5%
5%
5%
5%
R354
R355
R356
R357
R358
1-216-837-11
1-216-081-00
1-216-081-00
1-216-841-11
1-216-841-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
22K
22K
22K
47K
47K
5%
5%
5%
5%
5%
1/16W
1/10W
1/10W
1/16W
1/16W
R314
R315
R317
R318
1-216-057-00
1-216-073-00
1-216-057-00
1-216-081-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
10K
2.2K
22K
5%
5%
5%
5%
R359
R360
R361
R363
R364
1-216-821-11
1-216-864-11
1-216-821-11
1-216-809-11
1-216-065-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
RES, CHIP
1K
0
1K
100
4.7K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/10W
R319
1-216-081-00 METAL CHIP
22K
5%
R365
1-216-065-00 RES, CHIP
4.7K
5%
1/10W
28
SHORT
SHORT
SHORT
SHORT
METAL CHIP
1/16W
(C8500R)
1/16W
(C8500R)
1/10W
(C8500R)
1/16W
(C8500R)
1/16W
1/16W
(C8500X)
1/10W
1/16W
(C8500R)
1/16W
(C8500X)
1/16W
1/16W
(C8500R)
1/16W
(C8500X)
1/16W
1/10W
1/10W
1/16W
1/10W
1/10W
1/10W
1/10W
(C8500X)
1/10W
(C8500X)
SHORT
SHORT
SHORT
SHORT
1/10W
(C8500X)
1/10W
(C8500X)
1/10W
(C8500X)
1/10W
(C8500X)
1/10W
1/10W
(C8500X)
1/10W
(C8500X)
1/10W
(C8500X)
1/10W
(C8500X)
1/10W
(C8500X)
1/10W
(C8500X)
1/10W
(C8500X)
MAIN
Ref. No.
Part No.
Description
R366
R367
R368
R369
1-216-065-00
1-216-065-00
1-216-222-00
1-216-065-00
RES, CHIP
RES, CHIP
RES, CHIP
RES, CHIP
4.7K
4.7K
10K
4.7K
5%
5%
5%
5%
1/10W
1/10W
1/8W
1/10W
Remark
R370
R371
R372
R373
R374
1-216-065-00
1-216-833-11
1-216-833-11
1-216-222-00
1-216-222-00
RES, CHIP
METAL CHIP
METAL CHIP
RES, CHIP
RES, CHIP
4.7K
10K
10K
10K
10K
5%
5%
5%
5%
5%
1/10W
1/16W
1/16W
1/8W
1/8W
R375
R376
1-216-864-11 METAL CHIP
1-216-001-00 METAL CHIP
0
10
5%
5%
R377
1-216-001-00 METAL CHIP
10
5%
R378
1-216-001-00 METAL CHIP
10
5%
R379
1-216-001-00 METAL CHIP
10
5%
1/16W
1/10W
(C8500X)
1/10W
(C8500X)
1/10W
(C8500X)
1/10W
(C8500X)
R380
1-216-001-00 METAL CHIP
10
5%
R381
1-216-001-00 METAL CHIP
10
5%
R382
1-216-041-00 METAL CHIP
470
5%
R383
1-216-041-00 METAL CHIP
470
5%
R384
1-216-041-00 METAL CHIP
470
5%
R385
1-216-041-00 METAL CHIP
470
5%
R386
1-216-041-00 METAL CHIP
470
5%
R387
1-216-809-11 METAL CHIP
100
5%
R387
1-216-817-11 METAL CHIP
470
5%
R388
1-216-809-11 METAL CHIP
100
5%
R388
1-216-817-11 METAL CHIP
470
5%
R389
1-216-809-11 METAL CHIP
100
5%
R389
1-216-817-11 METAL CHIP
470
5%
R390
1-216-833-11 METAL CHIP
10K
5%
R390
1-216-864-11 METAL CHIP
0
5%
R391
1-216-073-00 METAL CHIP
10K
5%
R391
R392
1-216-295-11 SHORT
1-216-833-11 METAL CHIP
0 (C8500X)
10K
5%
R392
1-216-864-11 METAL CHIP
0
5%
R393
1-216-833-11 METAL CHIP
10K
5%
R393
1-216-864-11 METAL CHIP
0
5%
R398
1-216-041-00 METAL CHIP
470
5%
R408
1-216-822-11 METAL CHIP
1.2K
5%
1/10W
(C8500X)
1/10W
(C8500X)
1/10W
(C8500X)
1/10W
(C8500X)
1/10W
(C8500X)
1/10W
(C8500X)
1/10W
(C8500X)
1/16W
(C8500R)
1/16W
(C8500X)
1/16W
(C8500R)
1/16W
(C8500X)
1/16W
(C8500R)
1/16W
(C8500X)
1/16W
(C8500R)
1/16W
(C8500X)
1/10W
(C8500R)
1/16W
(C8500R)
1/16W
(C8500X)
1/16W
(C8500R)
1/16W
(C8500X)
1/10W
(C8500X)
1/16W
Ref. No.
Part No.
Description
Remark
R409
R412
1-216-073-00 METAL CHIP
1-216-829-11 METAL CHIP
10K
4.7K
5%
5%
1/10W
1/16W
R414
R415
R416
R417
R418
1-216-049-11
1-216-049-11
1-216-065-00
1-216-049-11
1-216-041-00
RES, CHIP
RES, CHIP
RES, CHIP
RES, CHIP
METAL CHIP
1K
1K
4.7K
1K
470
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R419
R420
R421
R501
R502
1-216-820-11
1-216-864-11
1-216-864-11
1-216-081-00
1-216-837-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
820
0
0
22K
22K
R502
1-216-864-11 METAL CHIP
R503
1-216-833-11 METAL CHIP
R503
1-216-841-11 METAL CHIP
R504
R505
1-216-025-11 RES, CHIP
1-216-295-11 SHORT
5%
1/16W
(C8500R: TYPE A, C8500X)
10K
5%
1/16W
(C8500R: TYPE B)
47K
5%
1/16W
(C8500R: TYPE C)
100
5%
1/10W
0 (C8500R)
R506
R507
R508
R509
R510
1-216-049-11
1-216-049-11
1-216-049-11
1-216-049-11
1-216-081-00
RES, CHIP
RES, CHIP
RES, CHIP
RES, CHIP
METAL CHIP
1K
1K
1K
1K
22K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
(C8500R)
R511
1-216-837-11 METAL CHIP
22K
5%
R512
R513
R514
1-216-821-11 METAL CHIP
1-216-049-11 RES, CHIP
1-216-049-11 RES, CHIP
1K
1K
1K
5%
5%
5%
R515
1-216-864-11 METAL CHIP
0
5%
1/16W
(C8500X)
1/16W
1/10W
1/10W
(C8500R)
1/16W
R516
R517
R518
R519
R521
1-216-845-11
1-216-049-11
1-216-833-11
1-216-809-11
1-216-809-11
METAL CHIP
RES, CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
1K
10K
100
100
5%
5%
5%
5%
5%
1/16W
1/10W
1/16W
1/16W
1/16W
R522
R523
R524
R526
R527
1-216-833-11
1-216-821-11
1-216-821-11
1-216-821-11
1-216-815-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
1K
1K
1K
330
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R528
R529
R530
R531
R532
1-216-821-11
1-216-049-11
1-216-845-11
1-216-821-11
1-216-821-11
METAL CHIP
RES, CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
100K
1K
1K
5%
5%
5%
5%
5%
1/16W
1/10W
1/16W
1/16W
1/16W
R533
R534
R535
R536
R537
1-216-809-11
1-216-845-11
1-216-821-11
1-216-821-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100K
1K
1K
100K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R538
R540
R541
1-216-049-11 RES, CHIP
1-216-069-00 METAL CHIP
1-216-081-00 METAL CHIP
1K
6.8K
22K
5%
5%
5%
R542
1-216-833-11 METAL CHIP
10K
5%
1/10W
1/10W
1/10W
(C8500R)
1/16W
5%
1/16W
5%
1/16W
5%
1/16W
5%
1/10W
5%
1/16W
(C8500R: TYPE C)
0
29
MDX-C8500R/C8500X
MAIN
Ref. No.
SUB
Part No.
Description
Remark
R543
1-216-097-11 RES, CHIP
100K
5%
1/10W
R544
R546
R547
1-216-845-11 METAL CHIP
1-216-081-00 METAL CHIP
1-216-837-11 METAL CHIP
100K
22K
22K
5%
5%
5%
R548
R549
1-216-845-11 METAL CHIP
1-216-049-11 RES, CHIP
100K
1K
5%
5%
1/16W
1/10W
1/16W
(C8500X)
1/16W
1/10W
R550
R551
R601
R602
R603
1-216-845-11
1-216-825-11
1-216-089-11
1-216-845-11
1-216-025-11
METAL CHIP
METAL CHIP
RES, CHIP
METAL CHIP
RES, CHIP
100K
2.2K
47K
100K
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/10W
1/16W
1/10W
R604
R605
R606
R607
R608
1-216-295-11
1-216-025-11
1-216-097-11
1-216-845-11
1-216-825-11
SHORT
RES, CHIP
RES, CHIP
METAL CHIP
METAL CHIP
0
100
100K
100K
2.2K
5%
5%
5%
5%
1/10W
1/10W
1/16W
1/16W
R609
R610
R611
R612
R614
1-216-833-11
1-216-025-11
1-216-841-11
1-216-089-11
1-216-298-00
METAL CHIP
RES, CHIP
METAL CHIP
RES, CHIP
METAL CHIP
10K
100
47K
47K
2.2
5%
5%
5%
5%
5%
1/16W
1/10W
1/16W
1/10W
1/10W
R615
R616
R617
R618
R701
1-216-073-00
1-208-806-11
1-216-025-11
1-216-025-11
1-218-871-11
METAL CHIP
METAL CHIP
RES, CHIP
RES, CHIP
METAL CHIP
10K
10K
100
100
10K
5%
0.5%
5%
5%
0.5%
1/10W
1/10W
1/10W
1/10W
1/16W
R702
R703
R704
R705
R706
1-218-871-11
1-216-829-11
1-216-829-11
1-216-833-11
1-216-041-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
4.7K
4.7K
10K
470
0.5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/10W
R708
R709
R710
R711
R712
1-216-821-11
1-216-821-11
1-216-821-11
1-216-821-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
1K
1K
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R713
R714
R715
R716
R717
1-216-295-11
1-216-049-11
1-216-049-11
1-216-845-11
1-216-864-11
SHORT
RES, CHIP
RES, CHIP
METAL CHIP
METAL CHIP
0
1K
1K
100K
0
5%
5%
5%
5%
1/10W
1/10W
1/16W
1/16W
R718
R719
R720
R721
R722
1-216-025-11
1-216-821-11
1-216-049-11
1-216-025-11
1-216-845-11
RES, CHIP
METAL CHIP
RES, CHIP
RES, CHIP
METAL CHIP
100
1K
1K
100
100K
5%
5%
5%
5%
5%
1/10W
1/16W
1/10W
1/10W
1/16W
R723
R724
R725
R726
R727
1-216-025-11
1-216-809-11
1-216-845-11
1-216-821-11
1-216-809-11
RES, CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100K
1K
100
5%
5%
5%
5%
5%
1/10W
1/16W
1/16W
1/16W
1/16W
R728
R729
R731
R732
R733
1-216-809-11
1-216-821-11
1-216-049-11
1-216-819-11
1-216-845-11
METAL CHIP
METAL CHIP
RES, CHIP
METAL CHIP
METAL CHIP
100
1K
1K
680
100K
5%
5%
5%
5%
5%
1/16W
1/16W
1/10W
1/16W
1/16W
Ref. No.
Part No.
Description
R734
R735
R736
R737
R738
1-216-845-11
1-216-864-11
1-216-025-11
1-216-025-11
1-216-025-11
METAL CHIP
METAL CHIP
RES, CHIP
RES, CHIP
RES, CHIP
100K
0
100
100
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/10W
1/10W
1/10W
Remark
R739
R740
R741
R742
R743
1-216-845-11
1-216-845-11
1-216-845-11
1-216-821-11
1-216-864-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
100K
100K
1K
0
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R901
R902
R903
R904
R905
1-216-817-11
1-216-821-11
1-216-821-11
1-216-833-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
470
1K
1K
10K
1K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
< SWITCH >
S101
S102
1-692-431-21 SWITCH, TACTILE (RESET)
1-771-540-11 SWITCH, PUSH (1 KEY) (NOSE DETECT)
< THERMISTOR >
TH101
TH102
TH103
1-801-792-21 THERMISTOR, POSITIVE
1-810-940-11 THERMISTOR, POSITIVE
1-810-940-11 THERMISTOR, POSITIVE
< TUNER UNIT >
TUX201 A-3320-738-A FM/AM TUNER UNIT (TUX-020)
< VIBRATOR >
X101
1-767-853-21 VIBRATOR, CRYSTAL (4.332MHz) (C8500R)
X103
1-567-098-41 VIBRATOR, CRYSTAL (32.768kHz)
X104
1-767-993-41 VIBRATOR, CRYSTAL (3.68MHz)
X105
1-781-822-21 VIBRATOR, CERAMIC (18.432MHz)
**************************************************************
*
1-677-865-12 SUB BOARD
**********
*
3-039-443-11 SHEET (CONNECTOR)
< CONNECTOR >
CN751
CN752
1-794-064-11 SOCKET, CONNECTOR 14P
1-770-736-21 SOCKET, CONNECTOR 14P
< LED >
LED751 8-719-077-75 LED BR1101F-TR (MD DISC SLOT) (C8500X)
LED751 8-719-077-78 LED BG1101F-TR (MD DISC SLOT) (C8500R)
< SWITCH >
9-870-096-81
LSW751 1-771-609-11 SWITCH, TACTILE (WITH LED) (Z) (C8500R)
LSW751 1-771-883-11 SWITCH, TACTILE (WITH LED) (Z) (C8500X)
< RESISTOR >
R754
1-216-186-00 RES, CHIP
330
5%
R754
1-216-194-00 METAL CHIP
680
5%
Sony Corporation
Audio Entertainment Group
30
1/8W
(C8500R)
1/8W
(C8500X)
2000H0552-1
Printed in Japan C 2000. 8
Published by General Engineering Dept.
MDX-C8500R/C8500X
MEMO
31
MDX-C8500R/C8500X
REVISION HISTORY
Clicking the version allows you to jump to the revised page.
Also, clicking the version at the upper right on the revised page allows you to jump to the next revised
page.
Ver.
1.1
1.0
Date
2001.05
2000.08
2000.02
Description of Revision
Change of Part No. for SPRING, FITTING
Supplement-1
New
(ECN-CSA04727)