Download Micon T20 Service manual

FILE NO. 050-200611GR
(MFR’S VERSION A)
SERVICE MANUAL
42" DIGITAL PLASMA
COLOR TELEVISION
42HP66
The above model is classified as a green product (*1), as indicated by the underlined serial number.
This Service Manual describes replacement parts for the green product. When repairing this green
product, use the part(s) described in this manual and lead-free solder (*2).
For (*1) and (*2), see the next page.
DOCUMENT CREATED IN JAPAN, March, 2006 GREEN
(*1)
GREEN PRODUCT PROCUREMENT
The EC is actively promoting the WEEE & RoHS Directives that define standards for recycling
and reuse of Waste Electrical and Electronic Equipment and for the Restriction of the use of
certain Hazardous Substances. From July 1, 2006, the RoHS Directive will prohibit any
marketing of new products containing the restricted substances.
Increasing attention is given to issues related to the global environmental. Toshiba Corporation
recognizes environmental protection as a key management tasks, and is doing its utmost to
enhance and improve the quality and scope of its environmental activities. In line with this,
Toshiba proactively promotes Green Procurement, and seeks to purchase and use products,
parts and materials that have low environmental impacts.
Green procurement of parts is not only confined to manufacture. The same green parts used in
manufacture must also be used as replacement parts.
(*2)
LEAD-FREE SOLDER
This product is manufactured using lead-free solder as a part of a movement within the consumer
products industry at large to be environmentally responsible. Lead-free solder must be used in
the servicing and repair of this product.
WARNING
This product is manufactured using lead free solder.
DO NOT USE LEAD BASED SOLDER TO REPAIR THIS PRODUCT !
The melting temperature of lead-free solder is higher than that of leaded solder by 86°F to 104°F
(30°C to 40°C). Use of a soldering iron designed for lead-based solders to repair product made
with lead-free solder may result in damage to the component and or PCB being soldered. Great
care should be made to ensure high-quality soldering when servicing this product  especially
when soldering large components, through-hole pins, and on PCBs  as the level of heat
required to melt lead-free solder is high.
A1-1
SERVICING NOTICES ON CHECKING
1. KEEP THE NOTICES
As for the places which need special attentions,
they are indicated with the labels or seals on the
cabinet, chassis and parts. Make sure to keep the
indications and notices in the operation manual.
2. AVOID AN ELECTRIC SHOCK
There is a high voltage part inside. Avoid an
electric shock while the electric current is
flowing.
11.When you remove the cover, do not scratch the
FPC on both ends of PDP Module.
12.Hold the four ends holder and be careful not to
touch the glass area.
13.Take care for the damage of vacuum exhaust
pipe due to a collision.
14.Moisture condensation may damage the PDP
Module.
So, leave it for 48 hours at the service room.
5. PUT PARTS AND WIRES IN THE
ORIGINAL POSITION AFTER
ASSEMBLING OR WIRING
3. USE THE DESIGNATED PARTS
The parts in this equipment have the specific
characters of incombustibility and withstand
voltage for safety. Therefore, the part which is
replaced should be used the part which has
the same character.
Especially as to the important parts for safety
which is indicated in the circuit diagram or the
table of parts as a
mark, the designated
parts must be used.
There are parts which use the insulation
material such as a tube or tape for safety, or
which are assembled in the condition that
these do not contact with the printed board.
The inside wiring is designed not to get closer
to the pyrogenic parts and high voltage parts.
Therefore, put these parts in the original
positions.
4. BE CAREFUL WITH THE PDP PANEL
1. When you handle the PDP Filter you must
wear the gloves twice, because, you are to
avoid soil it by your sweat and dust.
2. When you lift the PDP Filter you should hold it
with the palm of your hand.
Don’t pick up it with your fingers.
3. The back side of PDP Filter tends to damaged.
Since there is no coating.
Therefore, it put into the packing box at the
time of delivery, without piling up even at the
time of unused.
Also, when you take out it from a packing box,
be careful of the rubbing.
4. When the surface becomes dirty, wipe it with a
soft cloth as you draw a circle.
When it is dirty hardly, wipe it with a cloth
ethanol infiltrated.
Don’t use ethanol for the back side.
5. Do not apply it to direct sunshine so that the
characteristic may change.
6. When you inspect the surface (the scratch, the
dirt and the air bubble), use the fluorescent
light.
7. When you use SCREW DRIVER and SCREW,
be careful of a metallic powder being mixed.
8. Do not damage the PDP Module with a
DRIVER.
9. Do Handling with the PDP Module by 2
persons.
10.There is a step difference between the cover
and PDP Module.
So, when you remove the screws, place a
cushion on it so that the PDP Module is not
being scratched.
Then remove the screws carefully.
A1-2
6. PERFORM A SAFETY CHECK AFTER
SERVICING
Confirm that the screws, parts and wiring which
were removed in order to service are put in the
original positions, or whether there are the
portions which are deteriorated around the
serviced places serviced or not. Check the
insulation between the antenna terminal or
external metal and the AC cord plug blades.
And be sure the safety of that.
(INSULATION CHECK PROCEDURE)
1. Unplug the plug from the AC outlet.
2. Remove the antenna terminal on TV and turn
on the TV.
3. Insulation resistance between the cord plug
terminals and the eternal exposure metal
[Note 2] should be more than 2.5M ohm by
using the 500V insulation resistance meter
[Note 1].
4. If the insulation resistance is less than 2.5M
ohm, the inspection repair should be
required.
[Note 1]
If you have not the 500V insulation
resistance meter, use a Tester.
[Note 2]
External exposure metal: Antenna terminal
Screw
21pin jack
Side RCA jack
Rrar RCA jack
Headphone jack
HOW TO ORDER PARTS
Please include the following informations when you order parts. (Particularly the VERSION LETTER.)
1. MODEL NUMBER and VERSION LETTER
The MODEL NUMBER can be found on the back of each product and the VERSION LETTER can be
found at the end of the SERIAL NUMBER.
2. PART NO. and DESCRIPTION
You can find it in your SERVICE MANUAL.
IMPORTANT
When you exchange IC and Transistor with a heat sink, apply silicon grease (YG6260M) on the contact
section of the heat sink. Before applying new silicon grease, remove all the old silicon grease.
(Old grease may cause damage to the IC and Transistor).
PANEL LOCK
To unlock the Password of Panel Lock, please follow the steps below.
1. Turn Unit ON.
2. Press and hold the ‘VOLUME DOWN’ key on the front panel for more than 10 seconds.
3. The Panel Lock has now been cleared.
A1-3
TABLE OF CONTENTS
GREEN PRODUCT PROCUREMENT ........................................................................................
LEAD-FREE SOLDER ................................................................................................................
SERVICING NOTICES ON CHECKING .....................................................................................
HOW TO ORDER PARTS ..........................................................................................................
IMPORTANT ...............................................................................................................................
PANEL LOCK ..............................................................................................................................
TABLE OF CONTENTS ..............................................................................................................
GENERAL SPECIFICATIONS ...................................................................................................
DISASSEMBLY INSTRUCTIONS
1.EXCHANGE METHOD OF PDP MODULE ...........................................................................
2. REMOVAL AND INSTALLATION OF FLAT PACKAGE IC ..................................................
SERVICE MODE LIST ................................................................................................................
WHEN REPLACING EEPROM (MEMORY) IC ..........................................................................
RE-WRITE FOR DIGITAL SOFT FIRMWARE ...........................................................................
FUNCTION OF PCB ....................................................................................................................
ELECTRICAL ADJUSTMENTS ..................................................................................................
TROUBLESHOOTING GUIDE ...................................................................................................
BLOCK DIAGRAM
SCALER/LVDS/MICON/ADC/JACK/AV SWITCH1/REGULATOR .........................................
AV SWITCH2/STEREO/SOUND AMP ....................................................................................
TUNER/DIGITAL/POWER .......................................................................................................
INTERFACE .............................................................................................................................
MICON2 ...................................................................................................................................
PRINTED CIRCUIT BOARDS
AV/REMOCON ........................................................................................................................
SCALER ...................................................................................................................................
DIGITAL ...................................................................................................................................
OPERATION/SIDE JACK/FILTER ..........................................................................................
SCHEMATIC DIAGRAMS
AV SWITCH2 ...........................................................................................................................
TUNER/OUT JACK ..................................................................................................................
AV JACK ..................................................................................................................................
STEREO ..................................................................................................................................
SOUND AMP/HEADPHONE AMP ..........................................................................................
POWER ...................................................................................................................................
AV JACK2 ................................................................................................................................
IR PASS ...................................................................................................................................
TUNER .....................................................................................................................................
MICON .....................................................................................................................................
SCALER ...................................................................................................................................
ADC1 ........................................................................................................................................
ADC2 ........................................................................................................................................
LVDS ........................................................................................................................................
JACK ........................................................................................................................................
AV SWITCH1 ...........................................................................................................................
REGULATOR ...........................................................................................................................
INTERFACE_HDMI IC ............................................................................................................
HDMI MICON2 .........................................................................................................................
ASIC .........................................................................................................................................
SDRAM ....................................................................................................................................
FLASH .....................................................................................................................................
FRONT END ............................................................................................................................
AV OUT ....................................................................................................................................
POWER2 .................................................................................................................................
OPERATION/SIDE JACK/FILTER ..........................................................................................
INTERCONNECTION DIAGRAM ...............................................................................................
WAVEFORMS .............................................................................................................................
MECHANICAL EXPLODED VIEWS ...........................................................................................
MECHANICAL REPLACEMENT PARTS LIST .........................................................................
ELECTRICAL REPLACEMENT PARTS LIST ...........................................................................
A2-1
A1-1
A1-1
A1-2
A1-3
A1-3
A1-3
A2-1
A3-1~A3-5
B1-1~B1-8
B2-1, B2-2
C-1
C-2
C-3
C-4
D-1~D-5
E-1~E-7
F-1, F-2
F-3, F-4
F-5, F-6
F-7, F-8
F-9, F-10
G-1~G-4
G-5~G-8
G-9, G-10
G-11, G-12
H-1, H-2
H-3, H-4
H-5, H-6
H-7, H-8
H-9, H-10
H-11, H-12
H-13, H-14
H-15, H-16
H-17, H-18
H-19, H-20
H-21, H-22
H-23, H-24
H-25, H-26
H-27, H-28
H-29, H-30
H-31, H-32
H-33, H-34
H-35, H-36
H-37, H-38
H-39, H-40
H-41, H-42
H-43, H-44
H-45, H-46
H-47, H-48
H-49, H-50
H-51, H-52
H-53, H-54
I-1~I-3
J-1~J-3
K1-1~K1-3
K2-1~K2-8
GENERAL SPECIFICATIONS
G-1
TV
System
PDP
PDP Size / Visual Size
Number of Pixels(H x V)
Color System
Speaker
Main
Tweeter
Sound Output
G-2
Tuning
Broadcasting System
Analog
Tuner and
Receive CH
Digital
System
Destination
CH Coverage
System
Intermediate
Frequency
G-3
Signal
Power
Digital
Analog
Preset CH
Stereo/Dual TV Sound
Tuner Sound Muting
Video Signal
RGB Signal
Audio Signal
G-4
Position
Size
Impedance
Size
Impedance
MAX
10%(Typical)
Power Source
Power Consumption
Protector
G-5
Regulation
G-6
Temperature
G-7
G-8
Operating Humidity
Clock and
Clock
Timer
Sleep Timer
Picture(FP)
Sound(FS)
FP-FS
Input Level
Output Level
S/N Ratio (Weighted)
Horizontal Resolution at DVD Mode
Output Level
Input Level
Output Level
at DVD
at TV
Digital Output Level
S/N Ratio at DVD (Weighted)
Harmonic Distortion
Frequency Response :
at DVD
at Video CD
at SVCD
at CD
AC
DC
at AC
at DC
Stand by (at AC)
Per Year
Energy Star
Power Fuse
Safety Circuit
IC Protector(Micro Fuse)
Safety
Radiation
X-Radiation
Operation
Storage
Max Time
Step
Program
Program
On Timer
Off Timer
Game Timer
Wake Up Timer
Timer Back-up (at Power Off Mode)
more than
A3-1
42.32 inch / 1074.9 mmV
1024(H) x 768(V)
NTSC
4 Speaker
Front
2.2 x 5.0 inch
4 ohm
2.0 inch
8 ohm
10W + 10W
--US System
M
ATSC(8VSB)/QAM
1Tuner
USA(W/ CABLE)
2 - 69, 4A, A-5 - A-1,
A - I, J - W, W+1 - W+84
44.00MHz
45.75MHz
41.25MHz
4.50MHz
No
US-Stereo
Yes
1 V p-p/75 ohm
1 V p-p/75 ohm
-----8.0dBm/50k ohm
--8 dBm/1k ohm (0dBm=0.775Vrms)
0-600mV /1k ohm (Variable out mode)
0.5 V p-p/75 ohm
-0.02% (1KHz)
----120V AC 60Hz
--360 W at AC 120 V 60 Hz
-1 W at AC 120 V 60 Hz
-kWh/Year
Yes
Yes
Yes
No
UL/CSA
FCC/IC
--+/-0oC ~ +40oC
-20oC ~ +60oC
Less than 80% RH
Yes
120 Min
10 Min
Yes
No
Yes
No
-Min
Sec
GENERAL SPECIFICATIONS
G-9
Remote
Control
Unit
Glow in Dark Remocon
Remocon Format
Format
Custom Code
Power Source
Total Keys
Keys
Multi Brand Keys
Voltage(D.C)
UM size x pcs
Power
Input
Display
Mute
1
2
3
4
5
6
7
8
9
0
100 / +10
CH Return / Ent
CH +
CH VOL +
VOL SLEEP
Picture Size
UP
LEFT / FAV MENU/ENTER/DVD MENU
RIGHT / FAV +
DOWN
EXIT
TV
CBL/SAT
VCR
DVD
ENTER
PAUSE
PLAY
STOP
REW
FF
SKIP/SEARCH|<<
SKIP/SEARCH>>|
TOP MENU
REC
CLEAR
TV/VCR
A3-2
RC-KK
Yes
TOSHIBA
TOSHIBA
40-BF h
3V
UM-4 x 2 pcs
44
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
GENERAL SPECIFICATIONS
G-10
Features
Auto Shut Off
Power On Memory
Auto Search
DNR
Yes
Yes
No
Yes
3D
Yes
3D
Comb Filter
Just Clock Function
Game Position
Auto Setup(Language/CH Program)
Picture Setting(TV)
Mode(Picture Preference)
Brightness , Contrast , Color
Tint
Sharpness
Color Temperature
Cable Clear
Picture Setting(PC)
BRIGHTNESS , CONTRAST
HOR POSITION , VER POSITION
PHASE , CLOCK
AUTO ADJUST
RED , GREEN , BLUE
Audio
MTS
Tone Control (Bass/Treble/Balance)
Stable Sound
Surround
BBE
SRS WOW (SRS 3D/Focus/Tru Bass)
Valiable Audio Out
Tuning
CH Program
TV/Cable
ADD/ERASE
Screen Saver
Inversion(Reverse)
Full White(White)
Screen Saver(Picture Shift)
Side Panel Color
Label
CH Label
Video Label
Favorite CH
V-Chip
RRT Setup
Lock
Hotel Lock
Channel Lock
Video Lock
Panel Lock
OSD Language
Closed Caption
CC Advanced
Picture Size
Picture Scroll
Aspect
Backlight
PFC(Power Factor circuit)
Freeze frame
PIP/POP
Digital Out
Dolby Digital
MPEG
PCM
DTS
PC Monitor Input
VGA (640x480)
VGA (720x400)
WVGA (848x480)
SVGA (800x600)
XGA (1024x768)
WXGA (1280x768)
WXGA (1280x720)
WXGA (1360x768)
SXGA (1280x1024)
A3-3
No
No
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
No
Yes
Yes
Yes
Yes
No
No
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
Yes
No
No
Yes
Yes
Yes
English
French
Yes
Yes
Yes
Yes
Yes
No
Yes
No
No
Yes
No
Yes
No
Yes
Yes (60Hz)
No
Yes (60Hz)
Yes (60Hz)
Yes (60Hz)
Yes (60Hz)
Yes (60Hz)
Yes (60Hz)
No
GENERAL SPECIFICATIONS
HDMI Input
VGA (640×480)
720x480i (4:3)
720x480i (16:9)
720x480p (4:3)
720x480p (16:9)
720x576i (4:3)
720x576i (16:9)
720x576p (4:3)
720x576p (16:9)
1280x720p
1920x1080i
Component Input
G-11
Accessories
Owner's Manual
720x480i (4:3)
720x480i (16:9)
720x480p (4:3)
720x480p (16:9)
720x576i (4:3)
720x576i (16:9)
720x576p (4:3)
720x576p (16:9)
1280x720p
1920x1080i
Language
w/Guarantee Card
Remote Control Unit
Rod Antenna
Poles
Terminal
Loop Antenna (W/ Antenna Change Plug)
Terminal
U/V Mixer
DC Car Cord (Center+)
Guarantee Card
Warning Sheet
Circuit Diagram
Antenna Change Plug
Service Facility List
Important Safeguard
Dew/AHC Caution Sheet
Quick Set-up Sheet
Battery
UM size x pcs
OEM Brand
AC Adapter
AC Cord (for AC Adapter)
AC Cord
AV Cord (2Pin-1Pin)
HDMI-DVI Cable
Registration Card
300 ohm to 75 ohm Antenna Adapter
Information Sheet
Information Sheet(for IMPORTANT NOTICE)
Information Sheet(for PICTURE SHIFT)
A3-4
Yes
Yes (60Hz)
Yes (60Hz)
Yes (60Hz)
Yes (60Hz)
Yes (60Hz)
No
No
No
No
Yes (60Hz)
Yes (60Hz)
Yes
Yes (60Hz)
Yes (60Hz)
Yes (60Hz)
Yes (60Hz)
No
No
No
No
Yes (60Hz)
Yes (60Hz)
English / French / Spanish
Yes
Yes
No
No
No
No
No
No
No
No
No
No
No
No
Yes
UM-4 x 2 pcs
No
No
No
Yes
No
No
Yes
No
Yes
Yes
Yes
GENERAL SPECIFICATIONS
G-12
Interface
Switch
Indicator
Terminals
G-13
G-14
Set Size
Weight
G-15
Carton
Power (Tact)
System Select
Main Power SW
Channel Up/Menu Up
Channel Down/Menu Down
Volume Up/Menu >
Volume Down/Menu <
Input Select
Menu
Main Power SW
Power / Stand-by
On Timer
Rear
Video Input 1
Audio Input
S- Input
Video Input 2
Audio Input
S- Input
Video Output
Audio Output
Component In 1
Audio Input (Component In use)
Component In 2
Audio Input (Component In use)
Other Terminal
Euro Scart (21Pin)
PC Monitor Input (D-Sub)
Audio Input
HDMI Input 1
Audio Input(DVI 1)
HDMI Input 2
Audio Input(DVI 2)
Sub Woofer Out
Diversity
Digital Audio Out (Coaxial)
Digital Audio Out (Optical)
IR Pass Through
Ext Speaker
DC Jack 12V(Center +)
VHF/UHF Antenna Input(Digital/Analog)
AC Inlet
Side
Video Input 3
Audio Input
S- Input
Other Terminal
Approx.
W x D x H (mm)
Net Approx.
Gross Approx.
Master Carton
Content
Material
Dimensions
W x D x H(mm)
Description of Origin
Gift Box
Material
Dimensions
W x D x H(mm)
Design
Description of Origin
Drop Test
G-16
Material
G-17
Environment
Height (cm)
Container Stuffing
Cabinet
Cabinet Front
Cabinet Rear
PCB
Non-Halogen
Eyelet
Environmental standard requirement
Pb-free
A3-5
Yes
No
No
Yes
Yes
Yes
Yes
Yes
No
No
Yes(GREEN / RED)
No
RCA x 1
RCA x 2(L/MONO, R)
Yes
RCA x 1
RCA x 2(L/MONO, R)
Yes
RCA x 1
RCA x 2(Variable L, R)
RCA x 3
RCA x 2(L/MONO, R)
RCA x 3
RCA x 2(L/MONO, R)
No
No
Yes
RCA x 2(L/MONO, R)
Yes
PC Monitor Audio Input Alternative
Yes
Mini Pin Jack(3.5), STEREO
No
No
Yes
Yes
Yes
No
No
F Type
Yes
RCA x 1
RCA x2(L/MONO,R)
Yes
No
1,070 x 350 x 779.5
38.4kg
(84.7 lbs)
45.4kg
(100.1 lbs)
No
--- Sets
--- / ------Double/Brown
1,180 x 440 x 895
As per Buyer's
Yes
Natural Dropping At 1 Corner / 2 Edges /
4 Surfaces
50(ORION SPEC:31)
100
Sets/40' container
ABS 94V0 Non-DECABROM
Steel
No
Yes
Green procurement of TOSHIBA
Phase3(Pha
DISASSEMBLY INSTRUCTIONS
1. EXCHANGE METHOD OF PDP MODULE
NOTE
1. Do handling with the PDP Module by 2 persons.
REMOVAL METHOD OF PDP MODULE
1-1: CABINET BACK/COVER BACK
1. Remove the screw.
2. Remove the Cabinet Back and Cover Back.
Cabinet Back
Cover Back
1-2: STAND ASS'Y
1. Spread a sheet on the plane table and place the PDP Module carefully with the panel face down.
2. Remove the screw.
3. Remove the Stand Ass'y.
Stand Ass'y
B1-1
DISASSEMBLY INSTRUCTIONS
1-3: CHASSIS BLOCK
1. Disconnect the connector.
2. Remove the screw.
3. Remove the Chassis Ass'y.
Chassis Ass'y
1-4: PDP MODULE
1. Remove the screw.
2. Remove the Side Jack.
3. Hold the Frame Main carefully and remove the PDP Module.
NOTE
1. When removing the PDP Module, raise the cushion carefully so that you do not scratch the face.
Raise the cushion.
PDP Module
Frame Main
Frame Main
Side Jack
B1-2
DISASSEMBLY INSTRUCTIONS
1-5: PDP FILTER
1. Remove the screw.
2. Remove the Shield Main.
3. Remove the PDP Filter.
Shield Main Top
PDP Filter
Shield Main L
Shield Main R
Shield Main Bottom
B1-3
DISASSEMBLY INSTRUCTIONS
INSTALLATION METHOD OF PDP MODULE
NOTES FOR NEW PDP FILTER HANDLING
1. When you handle the PDP Filter, you must wear gloves to avoid soiling it with sweat and dust.
2. When you lift the PDP Filter, use the palm of your hand. Don’t pick it up with your fingers.
3. The back side of the PDP Filter tends to get damaged, since there is no coating. Therefore, it needs to be put into the
packing box at the time of delivery, even if it is not being used at the time. Also, when you take it out of the packing box, be
careful not to rub the appearance.
4. When the surface becomes dirty, use a cloth which is soft and dust free and wipe it in a circular motion.
When very dirty, lightly use alcohol on the cloth to wipe. Do not use alcohol for the back side.
5. Do not apply it to direct sunlight, the characteristics may change.
6. When you inspect for scratches and dirt, use a light to check for air bubbles on the PDP Filter surface.
1-6: PDP FILTER (PREPARATION)
1. Fix the cushion. (Order the cushion new.)
12345678901234567890123456789012123456789012345678
12345678901234567890123456789012123456789012345678
Cushion
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
Cushion
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
12
Rear side (No coating)
Cushion
123456789012345678901234567890121234567890123456789
123456789012345678901234567890121234567890123456789
Cushion
[4 ends common]
1234
1234
1234
1234
1234
1234
1234
1234
Apply the cushion on
1234
1234
the light brown paint
1234
1234
with 3mm on both
1234
1234
sides of the cushion.
1234
1234
1234
1234
1234
1234
1234
1234
1234
1234
1234
1234
1234
1234567890123456789012345
1234
1234567890123456789012345
1234
1234567890123456789012345
1234
1234567890123456789012345
1234
1234
1234
3mm
B1-4
3mm
DISASSEMBLY INSTRUCTIONS
NOTES FOR NEW PDP MODULE HANDLING
1. Handle the PDP Module with 2 people.
2. There is a step difference between the cover and the PDP Module, so when you remove the screws, place a cushion on it
to keep the PDP Module from being scratched. Then remove the screws carefully.
3. When you remove the cover, do not scratch the FPC on both ends of PDP Module.
4. Hold all four ends of the holder and be careful not to touch the glass area.
5. Be careful not to damage the vacuum exhaust pipe.
6. Moisture condensation may damage the PDP Module, so leave it in the service room for 48 hours.
7. Reuse the cover, vinyl sheet and screws when returning the PDP Module.
Vacuum Exhaust Pipe
FPC
B1-5
DISASSEMBLY INSTRUCTIONS
1-7: PDP MODULE (PREPARATION)
1. Remove the fixing screw of Power PCB. Then fix the Wiring Clip. (Use the clips on defective PDP Module)
2. Fix the Cord Clip. (Use the clips on defective PDP Module)
3. Fix the Wiring Clip. (Use the clips on defective PDP Module)
Wiring Clip
45˚
Set SW501 (24V)
Cord Clip
Cord Clip
B1-6
DISASSEMBLY INSTRUCTIONS
1-8: PDP MODULE
1.
2.
3.
4.
5.
Assemble the Frame Main. (Use the clips on defective PDP Module)
Install the PDP Filter on the set.
Install the Shield Main on the set.
Hold the Frame Main carefully and install the New PDP Module on the set.
Install the Side Jack on the set.
[NG]
Do not smash the cusion. (For all 2 positions)
[4 ends common]
123
123
123
123
123
123
123
123
Cushion 123
123
123
123
123
123
123
123
123
123456789012345
123
123456789012345
123
123456789012345
123
123
123
Pile up the cushion.
B1-7
DISASSEMBLY INSTRUCTIONS
1-9: CHASSIS BLOCK
1. Do the wire fixing as shown in the photo, then install the Chassis Ass'y.
2. Install the Stand Ass'y.
Earth wire of AC Inlet.
Sheet Earth Mark
Band Cord Clamp
Earth wire
Band Cord Clamp
1-10: CABINET BACK/COVER BACK
1.
2.
3.
4.
Check if the wire handlings are correct.
Check if the cushion positions are correct.
Check if the tape positions are correct.
Install the Cabinet Back and Cover Back.
B1-8
DISASSEMBLY INSTRUCTIONS
3. When IC starts moving back and forth easily after
desoldering completely, pickup the corner of the IC using a
tweezers and remove the IC by moving with the IC
desoldering machine. (Refer to Fig. 2-3.)
2. REMOVAL AND INSTALLATION OF
FLAT PACKAGE IC
REMOVAL
NOTE
1. Put Masking Tape (cotton tape) around the Flat Package
IC to protect other parts from any damage.
(Refer to Fig. 2-1.)
Some ICs on the PCB are affixed with glue, so be
careful not to break or damage the foil of each IC leads
or solder lands under the IC when removing it.
NOTE
Masking is carried out on all the parts located within 10
mm distance from IC leads.
Masking Tape
(Cotton Tape)
Blower type IC
desoldering
machine
IC
Tweezers
Fig. 2-1
IC
Fig. 2-3
2. Heat the IC leads using a blower type IC desoldering
machine. (Refer to Fig. 2-2.)
4. Peel off the Masking Tape.
NOTE
5. Absorb the solder left on the pattern using the Braided
Shield Wire. (Refer to Fig. 2-4.)
Do not rotate or move the IC back and forth , until IC
can move back and forth easily after desoldering the
leads completely.
NOTE
Do not move the Braided Shield Wire in the vertical
direction towards the IC pattern.
Blower type IC
desoldering machine
Braided Shield Wire
Soldering Iron
IC
IC pattern
Fig. 2-2
B2-1
Fig. 2-4
DISASSEMBLY INSTRUCTIONS
INSTALLATION
4. When bridge-soldering between terminals and/or the
soldering amount are not enough, resolder using a Thin-tip
Soldering Iron. (Refer to Fig. 2-8.)
1. Take care of the polarity of new IC and then install the new
IC fitting on the printed circuit pattern. Then solder each
lead on the diagonal positions of IC temporarily.
(Refer to Fig. 2-5.)
Thin-tip Soldering Iron
IC
Soldering Iron
Fig. 2-8
5. Finally, confirm the soldering status on four sides of the IC
using a magnifying glass.
Confirm that no abnormality is found on the soldering
position and installation position of the parts around the IC.
If some abnormality is found, correct by resoldering.
Solder temporarily
Solder temporarily
Fig. 2-5
2. Supply the solder from the upper position of IC leads
sliding to the lower position of the IC leads.
(Refer to Fig. 2-6.)
Solder
IC
NOTE
When the IC leads are bent during soldering and/or
repairing, do not repair the bending of leads. If the
bending of leads are repaired, the pattern may be
damaged. So, always be sure to replace the IC in this
case.
Soldering Iron
Supply soldering
from upper position
to lower position
Fig. 2-6
3. Absorb the solder left on the lead using the Braided Shield
Wire. (Refer to Fig. 2-7.)
NOTE
Do not absorb the solder to excess.
Soldering Iron
IC
Braided Shield Wire
Fig. 2-7
B2-2
SERVICE MODE LIST
This unit is provided with the following SERVICE MODES so you can repair, examine and adjust easily.
To enter to the SERVICE MODE function, press and hold both buttons simultaneously on the main unit and on the remote
control for more than the standard time in the appropriate condition. (See below chart.)
Set
Condition
Set Key
Remocon
Key
Standard
Time
TV mode
VOL. DOWN
(Minimum)
0
2 sec.
Releasing of V-CHIP PASSWORD.
TV mode
VOL. DOWN
(Minimum)
1
2 sec.
Initialization of factory TV data.
NOTE: If you set factory initialization, the memories are reset
such as the channel setting, and the POWER ON total
hours.
TV mode
VOL. DOWN
(Minimum)
6
2 sec.
Can be checked of the INITIAL DATA of MEMORY IC.
Refer to the "WHEN REPLACING EEPROM (MEMORY) IC".
ALL mode
VOL. DOWN
(Minimum)
8
2 sec.
Check of the SUM DATA, POWER ON total hours, MICON
VERSION and DIGITAL TV MICON FIRMWARE on the screen.
Refer to the "WHEN REPLACING EEPROM (MEMORY) IC".
ALL mode
VOL. DOWN
(Minimum)
9
2 sec.
Display of the Adjustment MENU on the screen.
Refer to the "ELECTRICAL ADJUSTMENT" (On-Screen Display
Adjustment).
Operations
C-1
WHEN REPLACING EEPROM (MEMORY) IC
CONFIRMATION OF CHECK SUM, POWER ON TOTAL HOURS, MICON VERSION AND
DIGITAL TV MICON FIRMWARE
Initial total of MEMORY IC, POWER ON total hours, MICON VERSION and Digital TV MICON Firmware can be checked on
the screen. Total hours are displayed in 16 system of notation.
NOTE: If you set a factory initialization, the total hours is reset to "0".
Please refer to "CONFIRMATION OF INITIAL DATA" when SUM DATA is not corresponding.
1. Turn on the POWER, and set to the TV mode.
2. Set the VOLUME to minimum.
3. Press both VOL. DOWN button on the set and Channel
button (8) on the remote control for more than 2 seconds.
4. After the confirmation of each check sum, POWER ON
total hours, MICON VERSION and Digital TV MICON
Firmware, turn off the power.
*1 DVP1 is different according to each set.
MICON Version
INIT
: 6082
VOLUME : 2E25
ROM
: 0000
ADC
: BFDE
DVP1
: EE40 *1
DVP2
: D172
PICENH : 5626
PDP ON :0001
OEC7147A_079
Initial setting data check sum.
VOLUME CURVE data check sum.
Rom correction data check sum.
AD CONVERTER data check sum.
SCALER data check sum.
DV1000 data check sum.
POWER ON total hours.
= (16 x 16 x 16 x thousands digit value)
+ (16 x 16 x hundreds digit value)
+ (16 x tens digit value)
+ (ones digit value)
CONFIRMATION OF INITIAL DATA
If a service repair is undertaken where it has been required to change the MEMORY IC, the following steps should be taken to
ensure correct data settings while making reference to INITIAL SETTING TABLE (Attached "INITIAL DATA").
1. Turn on the POWER, and set to the TV mode.
2. Set the VOLUME to minimum.
3. Press both VOL. DOWN button on the set and Channel button (6) on the remote control for more than 2 seconds.
ADDRESS and DATA should appear as FIG 2.
ADDRESS
DATA
INIT 0000 B4
PDP ON 0001
OEC7147A_079
DTV d-l62155
INIT :0000
ROM
: 0000
VOLUME : 2E25
FIG. 2
4. ADDRESS is now selected and should "blink". Using the UP/DOWN buton on the remote, step through the ADDRESS
until required ADDRESS to be changed is reached.
5. Press RIGHT/LEFT button to select DATA. When DATA is selected, it will "blink".
6. Again, step through the DATA using UP/DOWN button until required DATA value has been selected.
7. Pressing RIGHT/LEFT button will take you back to ADDRESS for further selection if necessary.
8. Repeat steps 4 to 6 until all data has been checked.
9. When satisfied correct DATA has been entered, turn POWER off (return to STANDBY MODE) to finish DATA input.
After the data input, set to the initializing of shipping.
10. Turn POWER on.
11. Press both VOL. DOWN button on the set and Channel button (1) on the remote control for more than 2 seconds.
12. After the finishing of the initializing of shipping, the unit will turn off automatically.
The unit will now have the correct DATA for the new MEMORY IC.
C-2
RE-WRITE FOR DIGITAL SOFT FIRMWARE
JG176 USA HD DTV ROM
DISC
Ref. No.
JG176
Part No.
APJG176095
Remarks
Parts Name
USA HD DTV ROM
DISC
Up-Date of the Firmware
NOTE: The operating manual for Re-writing is included in USA HD DTV ROM DISC (JG176).
Prepare the following tools for Up-Date of the Firmware.
1 Computer of WINDOWS2000
2 USB Flash Memory (Use only SanDisk Cruzer Mini USB Flash Drive 256Mb)
SET (REAR)
USB CONNECTOR
C-3
FUNCTION OF PCB
Y SUS
42 SANKEN PSU
TDRV TOP
POWER
Z SUS
YDRV BOT
XRLT
XRRT
CTRL
42 SANKEN PSU
Y SUS
Z SUS
CTRL
XRLT
XRRT
TDRV TOP
TDRV BOT
: A supplier which supplies voltage and current to each PCB and Panel.
: According to the timing provided from Panel Control, switches FETs and
generates driving waveform signal which is provided to Y electrode through
Scan Driver IC of TDRV TOP and TDRV BOT.
: According to the timing provided from Panel Control, switches FETs and
generates driving waveform signal which is provided to Z electrode through
Connector.
: Controls Y electrode, Z electrode, and ADDRESS electrode.
: Generates Address electrode and supplies to Address electrode by Driver IC.
: Generates Address electrode and supplies to Address electrode by Driver IC.
: Generates Scan electrode and supplies to Y electrode by Driver IC.
: Generates Scan electrode and supplies to Y electrode by Driver IC.
C-4
ELECTRICAL ADJUSTMENTS
1. ADJUSTMENT PROCEDURE
NO.
01
02
03
04
05
06
07
08
09
10
11
12
13
14
15
16
17
18
Read and perform these adjustments when repairing the
circuits or replacing electrical parts or PCB assemblies.
CAUTION
• Use an isolation transformer when performing any
service on this chassis.
• When removing a PCB or related component, after
unfastening or changing a wire, be sure to put the wire
back in its original position.
• When you exchange IC and Transistor with a heat sink,
apply silicon grease (YG6260M) on the contact section of
the heat sink. Before applying new silicon grease,
remove all the old silicon grease. (Old grease may cause
damage to the IC and Transistor).
Prepare the following measurement tools for electrical
adjustments.
FUNCTION
H POSI OSD
V POSI OSD
R DRIVE (N)
R CUT OFF (N)
G DRIVE (N)
G CUT OFF (N)
B DRIVE (N)
B CUT OFF (N)
R DRIVE (C)
R CUT OFF (C)
G DRIVE (C)
G CUT OFF (C)
B DRIVE (C)
B CUT OFF (C)
R DRIVE (W)
R CUT OFF (W)
G DRIVE (W)
G CUT OFF (W)
NO.
19
20
22
24
28
29
30
31
35
36
37
38
39
40
FUNCTION
B DRIVE (W)
B CUT OFF (W)
H POSI 60Hz
V POSI 60Hz
BRIGHT CENT
BRIGHT MAX
BRIGHT MIN
TINT
CONTRAST CENTER
CONTRAST MAX
CONTRAST MIN
COLOR CENT
COLOR MAX
COLOR MIN
Fig. 2-2
1. Pattern Generator
2-1: CONTRAST MAX
2. BASIC ADJUSTMENTS
1. Receive the monoscope pattern. (VIDEO Input)
2. Press the INPUT button on the remote control to set to the
AV mode.
3. Activate the adjustment mode display of Fig. 2-1 and press
the channel button (36) on the remote control to select
"CONTRAST MAX".
4. Press the VOL UP/DOWN button on the remote control
until the contrast step No. becomes "155".
5. Check if the picture is normal.
6. Receive the monoscope pattern. (RF Input)
7. Press the INPUT button on the remote control to set to the
TV mode.
8. Activate the adjustment mode display of Fig. 2-1 and press
the channel button (36) on the remote control to select
"CONTRAST MAX".
9. Press the VOL UP/DOWN button on the remote control
until the contrast step No. becomes "145".
10. Check if the picture is normal.
11. Receive the digital broadcast. (RF Input)
12. Perform the above adjustments 3 and 5.
13. Playback the DVD(480i) disc. (COMPONENT Input)
14. Press the INPUT button on the remote control to set to the
YUV mode.
15. Activate the adjustment mode display of Fig. 2-1 and press
the channel button (36) on the remote control to select
"CONTRAST MAX".
16. Press the VOL UP/DOWN button on the remote control
until the contrast step No. becomes "162".
17. Check if the picture is normal.
18. Playback the DVD(480i) disc. (HDMI Input)
19. Press the INPUT button on the remote control to set to the
HDMI mode.
20. Activate the adjustment mode display of Fig. 2-1 and press
the channel button (36) on the remote control to select
"CONTRAST MAX".
21. Press the VOL UP/DOWN button on the remote control
until the contrast step No. becomes "130".
22. Check if the picture is normal.
On-Screen Display Adjustment
1. Set the VOLUME to minimum.
2. Press the VOL. DOWN button on the set and the
channel button (9) on the remote control for more than
2 seconds to display adjustment mode on the screen as
shown in Fig. 2-1.
TV
AUTO
01 H POSI OSD
90
Fig. 2-1
3. Use the Channel UP/DOWN button or Channel button
(0-9) on the remote control to select the options shown
in Fig. 2-2.
4. Press the MENU button on the remote control to end
the adjustments.
5. To display the adjustment screen for AV, YUV, HDMI
and PC mode, press the INPUT button on the remote
control to set to the AV, YUV, HDMI and PC mode.
Press the VOL.DOWN button on the set and the
channel (9) on the remote control for more than 2
seconds.
D-1
ELECTRICAL ADJUSTMENTS
2-2: WHITE BALANCE
1. Place the set in Aging Test for more than 15 minutes.
2. Receive the gray scale pattern from the Pattern
Generator.
3. Press the INPUT button on the remote control to set to
the AV mode.
4. Using the remote control, set the brightness and contrast
to normal position.
5. Activate the adjustment mode display of Fig. 2-1 and
press the channel button (03) on the remote control to
select “R DRIVE (N)”.
6. Press the CH. UP/DOWN button on the remote control to
select the “R CUTOFF (N)”, “B.DRIVE(N)”, “B CUTOFF
(N)”, “R DRIVE (C)”, “R CUTOFF (C)”, “B.DRIVE(C)”, “B
CUTOFF (C)”, “R DRIVE (W)”, “R CUTOFF (W)”,
“B.DRIVE(W)”and “B CUTOFF (W)”.
7. Adjust the VOL. UP/DOWN button on the remote control
to whiten the R CUTOFF (N), B.DRIVE(N), B CUTOFF
(N), R DRIVE (C), R CUTOFF (C), B.DRIVE(C), B
CUTOFF (C), R DRIVE (W), R CUTOFF (W),
B.DRIVE(W) and B CUTOFF (W) at each step tone
sections equally.
8. Perform the above adjustments 6 and 7 until the white
color is looked like a white.
2-3: BRIGHT CENT
1. Receive the monoscope pattern. (VIDEO Input)
2. Press the INPUT button on the remote control to set to
the AV mode.
3. Set the screen mode to FULL.
4. Using the remote control, set the brightness and contrast
to normal position.
5. Activate the adjustment mode display of Fig. 2-1 and
press the channel button (28) on the remote control to
select "BRIGHT CENT".
6. Press the VOL. UP/DOWN button on the remote control
until the white 8.1% is starting to be visible.
7. Receive the monoscope pattern. (RF Input)
8. Press the INPUT button on the remote control to set to
the TV mode. Then perform the above adjustments 4~6.
9. Receive the digital broadcast. (RF Input)
10. Perform the above adjustments 4~6.
11. Playback the DVD(480i) disc. (COMPONENT Input)
12. Press the INPUT button on the remote control to set to
the YUV mode. Then perform the above adjustments
4~6.
13. Playback the DVD(480i) disc. (HDMI Input)
14. Press the INPUT button on the remote control to set to
the HDMI mode. Then perform the above adjustments
4~6.
D-2
ELECTRICAL ADJUSTMENTS
2-4: Confirmation of Fixed Value (Step No.)
Please check if the fixed values of each the adjustment items are set correctly referring below. (TV/AV/YUV/HDMI/PC/DTV)
YUV
TV
PC
AV
480i
NO.
HD-MI
480p
720p
1080i
480i
480p
720p
1080i
WXGA
VGA
SVGA
XGA
60*480
800*600
1024*768
1280*768
WVGA
WXGA
1280*720
848*480
1360*768
DTV
Step No.
FUNCTION
1
2
H POSI OSD
V POSI OSD
180
80
180
80
180
80
180
80
180
80
180
80
180
80
180
80
180
80
180
80
180
80
180
80
180
80
180
80
180
80
180
80
180
80
180
133
3
4
5
R DRIVE (N)
R CUT OFF (N)
G DRIVE (N)
133
129
128
133
129
128
133
129
128
133
129
128
133
129
128
133
129
128
133
129
128
133
129
128
133
129
128
133
129
128
120
...
122
120
...
122
120
...
122
120
...
122
120
...
122
120
...
122
120
...
122
133
129
128
6
7
G CUT OFF (N)
B DRIVE (N)
128
116
128
116
128
116
128
116
128
116
128
116
128
116
128
116
128
116
128
116
...
128
...
128
...
128
...
128
...
128
...
128
...
128
128
116
8
9
B CUT OFF (N)
R DRIVE (C)
135
123
135
123
135
123
135
123
135
123
135
123
135
123
135
123
135
123
135
123
...
...
...
...
...
...
...
...
...
...
...
...
...
...
135
123
10
11
12
13
14
R CUT OFF (C)
G DRIVE (C)
G CUT OFF (C)
B DRIVE (C)
B CUT OFF (C)
130
128
128
124
134
130
128
128
124
134
130
128
128
124
134
130
128
128
124
134
130
128
128
124
134
130
128
128
124
134
130
128
128
124
134
130
128
128
124
134
130
128
128
124
134
130
128
128
124
134
...
...
...
...
...
...
...
...
...
...
...
...
...
...
...
...
...
...
...
...
...
...
...
...
...
...
...
...
...
...
...
...
...
...
...
130
128
128
124
134
15
16
17
18
19
20
22
24
28
R DRIVE (W)
R CUT OFF (W)
G DRIVE (W)
G CUT OFF (W)
B DRIVE (W)
B CUT OFF (W)
H POSI 60Hz
V POSI 60Hz
BRIGHT CENT
135
129
128
128
107
137
282
24
107
135
129
128
128
107
137
282
24
107
135
129
128
128
107
137
282
24
107
135
129
128
128
107
137
142
24
115
135
129
128
128
107
137
312
24
115
135
129
128
128
107
137
260
24
115
135
129
128
128
107
137
278
24
95
135
129
128
128
107
137
140
24
95
135
129
128
128
107
137
268
24
95
135
129
128
128
107
137
218
24
95
...
...
...
...
...
...
47
22
50
...
...
...
...
...
...
214
22
50
...
...
...
...
...
...
158
22
50
...
...
...
...
...
...
190
20
50
...
...
...
...
...
...
189
20
50
...
...
...
...
...
...
110
22
50
...
...
...
...
...
...
365
20
50
135
129
128
128
107
137
294
24
115
29
30
31
BRIGHT MAX
BRIGHT MIN
TINT
185
60
117
185
60
121
185
60
121
185
60
126
185
60
126
185
60
126
185
60
123
185
60
123
185
60
123
185
60
123
100
30
...
100
30
...
100
30
...
100
30
...
100
30
...
100
30
...
100
30
...
185
60
137
35
36
37
CONTRAST CENTER
CONTRAST MAX
CONTRAST MIN
128
145
70
128
155
70
128
162
70
128
155
70
128
155
70
128
155
70
128
130
70
128
130
70
128
130
70
128
130
70
130
150
90
130
150
90
130
150
90
130
150
90
130
150
90
130
150
90
130
150
90
128
155
70
38
COLOR CENT
80
88
106
56
56
56
78
78
78
78
...
...
...
...
...
...
...
60
39
40
COLOR MAX
COLOR MIN
180
0
180
0
180
0
180
0
180
0
180
0
180
0
180
0
180
0
180
0
...
...
...
...
...
...
...
...
...
...
...
...
...
...
180
0
D-3
D-4
ELECTRICAL ADJUSTMENTS
3. ELECTRICAL ADJUSTMENT PARTS LOCATION GUIDE (WIRING CONNECTION)
PDP PANEL
CP2200
CP7202
CP802
CP803
J4211
J4204
SCALER PCB
AV PCB
SIDE JACK PCB
CP2251
J4209
CP4200
REMOCON PCB
J4208
J4207
J4206
CP2203
CP3901
OPERATION PCB
CP3900
FILTER PCB
CD3810
AC IN
D-5
J3601
J4205
CP3603
CP4302
J4202
CP3601
CD4204
CP3602
CD4203
J4301
CP901
CP3201
CP4202
CP4204 CP4203
CP4201
TU5801
J2275
J4201
CP301 CP303
SPEAKER
DIGITAL PCB
CP3807
CP3804
SPEAKER
CP3802
CP3801 CP3803
TROUBLESHOOTING GUIDE
POWER DOES NOT TURN ON
IS F3900 BROKEN ?
YES
CHANGE F3900.
NO
IS THERE VOLTAGE
AT PIN 11 OF CP3201
5V ?
NO
CHECK CP3201 AND
CP3804.
NO
CHECK IC3804 AND
PERIPHERAL CIRCUIT.
OR CHANGE AV PCB.
YES
IS THERE VOLTAGE
AT PIN 2 OF IC3804
AT3.3V ?
YES
CHANGE SCALER PCB.
E-1
TROUBLESHOOTING GUIDE
THE PICTURE DOES NOT
APPEAR (1).
IS CD3201 CONNECTED ?
NO
CONNECT CP3201.
YES
IS CD7204 CONNECTED ?
NO
CONNECT CD7202.
YES
IS THERE SIGNAL
AT IC7202 ?
NO
CHANGE IC7202.
YES
CHECK IC801.
OR CHANGE SCALER PCB.
E-2
TROUBLESHOOTING GUIDE
THE PICTURE DOES NOT
APPEAR (2).
IS THERE SIGNAL
AT IC4201 ?
NO
CHECK IC4201 AND
PERIPHERAL CIRCUIT.
NO
CONNECT CD4203.
CHECK IC4201 AND
PERIPHERAL CIRCUIT.
YES
IS CD4203 CONNECTED
AND IS THERE SIGNAL ?
YES
CHECK IC801 AND
PERIPHERAL CIRCUIT.
E-3
TROUBLESHOOTING GUIDE
THE PICTURE APPEARS, BUT
THE AUDIO DOES NOT
APPEAR.
IS CD301 AND CD303
CONNECTED ?
NO
CONNECT CD301 AND CD303.
YES
IS THERE SIGNAL
CD301 AND CD303 ?
YES
CHANGE SP301 AND SP302.
NO
IS THERE SIGNAL
AT PINS 11 AND 15
OF IC301 ?
YES
CHECK IC301 AND
PERIPHERAL CIRCUIT.
NO
IS THERE SIGNAL
AT PINS 27 AND 28
OF IC904 ?
NO
CHECK IC904 AND
PERIPHERAL CIRCUIT.
YES
CHANGE AV PCB.
E-4
TROUBLESHOOTING GUIDE
THE STOP PICTURE
"PLEASE WAIT".
IS CD3806 CONNECTED ?
NO
CONNECT CD3806.
YES
IS DIGITAL PCB
CONNECTED ?
NO
CONNECT DIGITAL PCB.
YES
IS THERE VOLTAGE
AT PINS 1 AND 2 OF
CD3806 5V ?
NO
CHECK Q512, IC509 AND
PERIPHERAL CIRCUIT.
YES
CHANGE DIGITAL PCB.
E-5
TROUBLESHOOTING GUIDE
THE COLOR DOES NOT
APPEAR.
IS SETTING OF
COLOR NORMAL ?
NO
CHANGE THE SETTING OF
COLOR.
YES
IS THE COLOR
SIGNAL RECEIVED ?
NO
RECEIVE THE COLOR SIGNAL.
YES
IS THERE SIGNAL
AT IC801 ?
NO
CHECK IC801 AND
PERIPHERAL CIRUCUIT.
NO
CHECK IC2101 AND
PERIPHERAL CIRUCUIT.
YES
IS THERE SIGNAL
AT IC2101 ?
YES
CHANGE SCALER PCB.
E-6
TROUBLESHOOTING GUIDE
ON SCREEN DISPLAY DOES
NOT APPEAR.
IS THERE SIGNAL AT
PINS 2, 3, 4 AND 5 OF
IC101 ?
NO
CHECK IC101 AND
PERIPHERAL CIRCUIT.
YES
IS THE COLOR SIGNAL
AT PINS 57, 58, 59 AND
60 OF IC801 ?
NO
CHECK IC801AND
PERIPHERAL CIRCUIT.
YES
CHANGE SCALER PCB.
E-7
SCALER/LVDS/MICON/ADC/JACK/AV SWITCH1/REGULATOR BLOCK DIAGRAM
DIGITAL RGB
A/D CONVERTER
IC2101
MST9883C-LF-110
DDVS
INTERFACE
DDHS
VGA_HS
56
DIGITAL
24bit RGB
D_CLK, D_EN,
D_HS, D_VS
DIGITAL
24bit RGB
D_CLK, D_EN,
D_HS, D_VS
58
27
28
SCALER
IC801
R8J66604A72FP
84
57
VGA_VS
X801
54MHz
LVDS IC
IC7202
DTC34LM85AL
TX OUT0~3+
TX OUT0~3TXCLKOUT+
TXCLKOUT-
PDP PANEL
V801
PDP42X3
85
57
60
SW_CVBS
SW_Y
SW_C
4SI_SDA_IN/4SI_SCL
4SI_CHIP_SE/4SI_SDA_OUT
SCART1_B_IN
AV SWITCH2/
STEREO/
SOUND AMP
SCART1_G_IN
EEPROM IC 256K
IC103
AT24C256N-10 SU-2.7
6
EEP_SCL
5
EEP_SDA
SCART1_R_IN
EEPROM IC 256K
IC104
AT24C256N-10 SU-2.7
2
AUDIO_MUTE
58
SCL
27
SDA
28
MICON
IC101
OEC7147A
74 90 17 89 10 14
PSU_5VD
TUNER/DIGITAL/
POWER
5
54
6
EEP_SCL
53
5
EEP_SDA
POWR_ON-H
33 34
DTUNER RX
LCD_H
DTUNER TX
TUNER/DIGITAL/
POWER
POWER_FAIL
LCD_ON
1
2
SYSTEM RESET
IC102
PST3229NR
RESET
AT+3.3V
P.CON+3.3V REG
IC3201
BA00BC0WFP
D105
2
SCALER_H
6
1
4
P.CON+3.8V
P.CON+3.3V
P.CON+1.5V REG
IC3202
BD7820FP
2
6
1
4
P.CON+1.5V
F-1
F-2
AV SWITCH2/STEREO/SOUND AMP BLOCK DIAGRAM
AV SW
IC4201 AN15853B-E1
24 SDA
25 SCL
28 SW_A_IN_R
INPUT 1/2
J4205 YKC22-0780N
V1-V
2
14
V1-Y
4
3
V1-C
6
4
V1-L
3
17
VL-R
5
20
V1-L
20
9
VL-R
22
10
V2-V
9
15
V2-R
12
18
V2-L
10
22
30 SW_A_IN_L
SW_CVBS
SCALER/LVDS/
MICON/ADC/JACK/
AV SWITCH1/
REGULATOR
31 SW_CVBS
SW_Y
33 SW_Y
SW_C
35 SW_C
V_OUT
SIF_OUT
TUNER/DIGITAL/
POWER
AUDIO_IN 4/5
J4204 AU4-57A03-01H
2
5
16 TUNER_V
V4-L
19
3
V4-R
21
7
STEREO
IC904 MSP4440G-QA-C13-100
PC_A_L
COMPONENT
IC4204
NJM2584AM(TE1)
56 SC1_IN_L
PC_A_R
9
14 U
V
1
Y
8
16 V
67 ANA_IN1+
57 SC1_IN_R
YUV/HDMI/DVI Lch SW
IC4304 NJM2534V
SW_A_L
INTERFACE
53 SC2_IN_L
YUV/HDMI/DVI Rch SW
IC4305 NJM2534V
AV2_IN_L
50
AV2_IN_R
51
COMPONENT
IC4401
NJM2584AM(TE1)
9 14 1
54 SC2_IN_R
SW_A_R
XTAL_IN
5
6
14
3
11
5
8
6
71
X901
18.432MHz
XTAL_OUT
AUDIO_MUTE
MICON2
9
6
9
SCART1_G_IN
1
3
SCART1_B_IN
11
SCART1_R_IN
SCALER/LVDS/
MICON/ADC/JACK/
AV SWITCH1/
REGULATOR
8 16
2
DTUNER_V
3
37 VARIOUT_L
DTUNER_U
TUNER/DIGITAL/
POWER
DTUNER_Y
HDMI_I2SS
4
I2S_CL
3
HDMI_I2SSDO
7
I2S_DA_IN
2
HDMI_I2SWS
5
I2S_WS
SOUND AMP IC
IC301 TA2024-ASE
SPOUT_R
27
11 INV2
SPOUT_L
28
15 INV1
VGA_B
VGA_G
VGA_R
33 VDDA
SCALER/LVDS/
MICON/ADC/JACK/
AV SWITCH1/
REGULATOR
SPEAKER
SP303
30 VDD1
SOUND+B
3
36 VARIOUT_R
4
TUNER/DIGITAL/
POWER
8
6
AUDIO_OUT_JACK
J4201
CP901
5
5
3 I2C_DA
SDA
SCALER/LVDS/
MICON/ADC/JACK/
AV SWITCH 1/
REGULATOR
U
2
14
72
2 I2C_CL
SCL
11
SW
IC8104
NJM2584
3
Y
CS_IN 4/5
J4211 YKC21-4720N
12 MUTE
OUTP1 31
29 VDD1
OUTM1
26 VDD2
OUTM2 27
25 VDD2
OUTP2 24
28
SPEAKER
SP301
SPEAKER
SP302
SPEAKER
SP304
F-3
F-4
TUNER/DIGITAL/POWER BLOCK DIAGRAM
4
AA
CLKAB
4
REG 1.8V
IC3403
BD7820FP
2
EEP ROM
IC2404
BR24L64-WE2
+3.3V
SCL
V_OUT
+5V
SIF
IF_OUT1
IF_OUT2
4
7
9
10
13
14
15
19
20
UNREG 4V
4
+1.2V
X2401
55.474MHz
X2402
25.140MHz
2
2
UNREG 5V
256Mbit DDR SDRAM
IC2403
HY5DU561622ETP-D43
DQA
AA
CLKAB
DQA
256Mbit DDR SDRAM
IC2402
HY5DU561622ETP-D43
REG 3.3V
IC3402
BA00BCWEP
SDA
UNREG 5V
9
+5V
DC/DC CTL
IC3401
AL1042
+32V
1
+5V
TU5801
REG 2.6V
IC3404
BA7810HFP
2
UNREG 4V
+3.3V
ATSC/CLER CABLE ASIC
IC2401
X240H
I2CDATA
+1.8V
DTUNER Y
+2.6V
DTUNER U
DTUNER V
Y OUT
U OUT
V_OUT
V OUT
SIF_OUT
DTUNER RX
DTUNER TX
I2CCLKA
FAD
AV SWITCH2/
STEREO/
SOUND AMP
SCALER/LVDS/
MICON/ADC/JACK/
AV SWITCH1/
REGULATOR
TUNER SCL
TUNER SDA
FLASH MEMORY
IC2406
HY27US0828IA-TP
T_FAT_IFP
T_FAT_IFN
+3.3V
DC-DC CONVERTER
IC3803
BD9300FV-E2
CP3801
1
SOUND+B
2
SOUND+B
SOUND+B
8
5
CP3803
1
3
2
AT+3.3V REG
IC3804
PQ070XF01SZH
1
5VSC
2
5VSC
AT+3.3V
3
5VSC
AT+5V
7
12VSC
8
12VSC
P.CON+12V
P.CON32V REG
IC3805
LA7995M-TLM
CP3802
1
9VSC
14
1
POWER FAIL
3.3V CONTROL
IC3801
AL1010
2
LDC_H
1
CP3804
3
AV SWITCH2/
STEREO/
SOUND AMP
7
CHOPPER
IC3802
RSS050P03
4
7
5
P.CON+3.8V
AT+5V
5
5VD/LIGHT_CTL
6
POWER_ON_H
P.CON+9V
PSU_5VD
SCALER/LVDS/
MICON/ADC/JACK/
AV SWITCH1/
REGULATOR
LVD_ON
LCD_H
POWER_FAIL
F-5
F-6
INTERFACE BLOCK DIAGRAM
EEP_ROM
IC3606 BR24L02F-WE2
5 SDA GND
4
5 SDA GND
4
6 SCL
A2
3
6 SCL
A2
3
7 WP
A1
2
7 WP
A1
2
8 VCC
1
A0
1
Q16 119
Q3616
BUFFER
BUFFER
Q3604
HDMI
CONNECTOR
CP3601
BUFFER
Q3612
30 DSCL1
31 DSDA0
32 DSCL0
Q3613
SW
SW
L3601
ACM2012D
1
2
39 R0XC-
4
3
40 R0XC+
L3603
ACM2012D
1
2
L3602
ACM2012D
1
2
4
2
Q11 129
Q7
132
Q6
136
Q5
137
Q4
140
Q0
144
3
L3604
ACM2012D
3
86
WS
85
47 R0X1-
SD0
84
48 R0X1+
OVCC
5
OVCC
6
1
4
51 R0X2-
OVCC 26
2
3
52 R0X2+
OVCC 76
OVCC 89
4
3
2
L3606
ACM2012D
DDHS
3.3VREG
IC3602 BA00BCWFP
1
2
3
4
2
3
2
PC_A_R
4
PC_A_L
AV SWITCH2/
STEREO/
SOUND AMP
AUDIO_IN
J3601
OVCC 109
2
SW_A_R
59 R1XC+
OVCC 122
4
SW_A_L
OVCC 134
4
3
62 R1X0-
CSCL
63 R1X0+
CSDA 29
28
1.8VREG
IC3601 KIA78D33F
1
2
3
RESET# 102
1
SCALER/LVDS/
MICON/ADC/JACK/
AV SWITCH1/
REGULATOR
PC AUDIO_IN
J4301
58 R1XCL3607
ACM2012D
1
DDCK
2
SCK
44 R0X0+
DIGITAL RGB
ODCK 121
VSYNC
43 R0X0-
L3608
ACM2012D
1
Q12 126
HSYNC
4
3
Q15 123
OUT
Q3603
29 DSDA1
OUT
BUFFER
D-SUB
CP4302
1 VGA-R
2 VGA-G
3 VGA-B
13 VGAHS
14 VGAVS
113
Q19 116
Q3615
19 DET
18 POWER
17 GND
16 SDA
15 SCL
12 CLK10 CLK+
9 D07 D0+
6 D14 D1+
3 D21 D2+
HDMI
CONNECTOR
CP3603
19 DET
18 POWER
17 GND
16 SDA
15 SCL
12 CLK10 CLK+
9 D07 D0+
6 D14 D1+
3 D21 D2+
Q20
GND
A0
110
GND
VCC
Q23
IN
8
HDMI INTERFACE
IC3605 SiI9021CTU
IN
EEP_ROM
IC3609 BR24L02F-WE2
66 R1X167 RX1+
L3605
ACM2012D
INT 104
EXT_RES 81
DVCC2 94
V_SYNC
SCK
WS
SDO
1
4
70 R1X2-
VCC 92
CSCL
2
3
71 R1X2+
VCC 79
CSDA
MICON2
DVCC 74
VCC 114
VGA-R
VGA-G
VGA-B
VGA_HS
VCC 128
VGA_VS
DACDVCC 22
RXT_RST#
H_INT
VCC 139
VCC 23
VCC 35
F-7
F-8
MICON2 BLOCK DIAGRAM
HDMI MICON IC
IC3611
SST89E58RD2-40-C-TQJE
36 RX1_RST
RXT_RST#
8 RX1_INT
H_INT
X1 15
X2 14
X3601
11.0592MHz
38 VCC
29
CSDA
Q3606
BUFFER
EA-/VPP
V-SYNC 41
Q3620
LEVEL SHIFT
V_SYNC
INTERFACE
3 CSDA
EEP ROM IC
IC3608
BR24L32F-WE2
1 A0
2 A1
3 A2
INTERFACE
4 GND
CSCL
VCC
8
WP
7
SCL
6
SDA
5
2
CSCL
Q3605
BUFFER
SDO
SCK
WS
CP3602
AV SWITCH2/
STEREO/
SOUND AMP
F-9
4
HDMI_I2SS
3
HDMI_I2SSDO
2
HDMI_I2SWS
F-10
PRINTED CIRCUIT BOARDS
AV/REMOCON (TOP SIDE)
CEF179A
L3810
C3801
R4401
R4402
W870
R3806
R3805
R3801
R3808
L3803
L3804
L3801
C3817
C3821
W839
C365
C904
C364
R311
C3805
C3803
W001
L3809
CP4204
Q4403
C4406
Q301
Q302
W802
C5838
C5839
Q4409
Q4401
C4408
R4419
C4243
C4203
C320
W857
W856
C319
C4242
L4202
R3855
CP5802
R4256
L901
C3826
R324
C906
C3827
L3811
L4401
C3848
D3804
W848
W917
C304
R3802
C3802
W821
R3822
C3825
L3808
C2255
R3825
D3803
C3849
D4209
W919
Q2251
C2256
R2257
L303
CP301
CP303
R4408
C4403
R4231
CP4203
C4401
W914
CP5801
C4233
IC301
C339
C4252
L4203
L4206
L4207
TU5801
W851
S801Y
C2282
R4241
W893
W894
W892
C949
R906
R905
R902
R903
C922
C4232
C4230
C962 C963
C933
D4205
C324
L2275
L4201
R4245
C341
W915
C4261
C4260
C4265 R4410
R4223
C4256
R4409
C4407
R4230
R4411
IC4401
R4406
C4404
C5809
C4402
C5812
C5810
C5806
C5813 R5809 C5814 R5813R5810
Q5803
R5814
R5816
R5815
C5807 R5808R5811
R5807R5812
L5802
W908
C4220
C4415
C4250
D4212
D4210 C4251 C4416
C4247
C4246
R4212
R4209
C915
C950
C952
C918
C914
C927
C946
C951
X901
C4273
L302
L5804
R4261
C919
W910
W911
C3834
C3835
C3836
L4403
C3829
C3830
IC2275
C2278
R2278
L4220
C3833
C3832
C3837
D3805
C5803
L4402
C4412
L4217
L4215
L4216
L4213
C4464
C4449
C4453
C4452
C4451
R4254
C4296 C4450
C4448
R4252
C4297
B4215
L4219
L4218
C4461
C337
C4279
R4208
C4266
R4206
W834
R4207
C916
C4237
R4229
R4232
C340
R2281
R2282
C2276
C2279
J4202
D2275
J4204
J4211
J4205
L3805
C3823
C2252
D2252
C342
R320
Q4202
L4204
W876
Q4402
C2275
D4206
D4207
L4212
L4214
C2277 R2279
W869
R4236
R4235
Q4207
R4418
IC4201
C5820
C5819
CP4201
R901
B4216
IC4204
Q4209
L3802
G-2
G-1
C326
CP901
R4233 Q4208
Q4210
S801X
25
1
L301
Q4201
L300
Q5804
C4264
R4234
R5806
IC904
R318
C331
R317
41
65
C4218
C4207
C4224 C4222 C4227
C4206 C4223
C4217 C4205
C4215 D4211C4214
C4229
C953
C955
C323
C332
R319
C948
Q5805
Q4410
R4405
L904
C941
C328
W885
R4404
R4417
B902
D4208
R4416
L903
C4202C4239
C4201C4238
R4407
R4412
B903
B901
CMF083A
R3849
R4403
L4211
HS3808
IC3804
IC3808
R2252
R325
CP2251
CP3807
W889 R2259
D901
W890
Q2252
Q3805
C3839
R3824
D2251
Q3804
HS3801
L5803
HS300
R321
OS4202
C2280
J4201_1
R2287
Q2275
R2285
Q3808
Q300
R2256
L4221
R2280
OS2251
CP3804
CP3802
CP3803
CP3801
W945
CP4202_1
J2275
G-3
R4238
R2277
R2275
Q2277
C363
C352
C349
C348
D302
R2283
W907
D303
R338
R315
C957
C301
C354
C350
D304
D305
R2276
R4263
B4225
C338
C956
C944
C926
R304
C359
C362
C358
C351 C353
C355
C959
C903
CMF083A
C2281
C4301
R4237
R4461
R4203
R4204
C4234
B4202
C943
R314
R4205
C4236
R4239
R4247
B906
B905
B904
C945
C954
C940
C942
R4243
B4461
C4462
R4246
C4275
R4244
Q4200
C4272
C4274
C4271
R904
R916
C936
C934
R3858
R3857
C3847
R2253
R3823
R3821
R3820 C3816
D3809
R3830
C3819
R3856
C3806
R2255
R2254
C3822
IC3803
R4248
C4277
R4249
C4283
B4214
B4221
R4251
R4250
C4288
C909
C958
R3835
R3831
D3806
B4217
R4253
C4455
B4222
R4240
R4298
R4255
C4454
B4219
C4278
B4211
C920
R302
R3834
D3812
R3826
R3833
C4414
R3832
W842
D3808
Q3806
B2271
B4220
C4258
C917
R4219
R4220
Q3802
R3828
R2288
B4205
IC5801
R4262
R4295
R4297
R4259
C4276
C4208
C4225
D4202
C4228
Q4233
C4284
R4294
B4218
R4296
R4260
C4290
W865
W867
C4221
C4456
D4203
C4216
R323
R4242
R4299
C4226
W902
B4204
C4469
IC4402
C4282
C4285
C4211
Q4205
C4210
Q5802
C4289
R4211
C4213
C4471
C4231
R4216
C4286
C4287
C5811
C5805
C3804
C4413
R3803
C2283
R2289
IC3805
B5805
Q5801
C5817
B5803
D3811
D3807
Q902
B5801
C5815
W928 Q4206
R914
W901
B5802
C5801 C5802
C5816
R913
R915
C5808
W886
R4415
R322
D306
R4420
W903
W898
Q3801
C4300
C3828
C4405
W852
Q901
C3831
C4240
R4210
R4225
R4228
W929
Q4231
W900
W899
R4213
Q4203
R4214
PRINTED CIRCUIT BOARDS
AV/REMOCON (BOTTOM SIDE)
CEF179A
Q3807
W836
R3827
Q4211
Q2276
R2284
R2286
G-4
G-5
CP3201
W857
R118
R147
R129
R146
R126
R122 R123
R121 R120
R119 R134
CP7202
IC104
W990 C109
X101
R128
26
R145
IC101
51
R151
CP102
R149
D105 R114
R115
CP103
R173
CP101
NR807 NR806 NR805 NR804 NR803 NR802
D109
W1018
R2115
W1016
CP802
W981
IC2101
W823
W874
W985
NR2101 NR2102 NR2103 NR2104
W1017
C2121
C2127
41
R8124
C801
C815
C2103
R2109
C2133
C2802
W877
W982
R8122
C110
C128
R164 W907
1
R163
R127 R110
W967
C101
L2103
C2139
D4302
IC3202
61
C2149
Q2101
R2114
C4378
R7505
R2112
D4301
C891
C892
C8151
L8105
CP803
C8149
C8126
C8122
W1014 W964
L8104
C4372
CEF156A
C8120
C8121
C8131
W900
C116
R833
W963
Q105 Q101
163
W843
C8123
W944
W972
R141 R142
W905
C868
C131
C858
IC102
R2107
C2106
1
C2130
D802
C136
109
C883
C830
C832
C834
C859
C876
23
C125
NR7501 NR7502
IC801
R135
IC7501
55
NR2105 NR2106
D803
C7208
C810
D805
C863 C860 C857
NR801
W968
IC103
D3206
R825 C861
1
C7209
1
C4362
C8124
C8125
C4328
C4337
C4366
R4313
C4324
C3600
C4315
C2801
R830
IC3608
B804
33
R4314
C4314
R3600
D3603
D3601
R3601
L3601
L3603
L3602
L3604
C3685 R3638
B4307
CP4302
C7219
C7503
C850
L4306
NR3606 NR3605 NR3604 NR3603
L3623
B4308
B801
97
R7507
65
X801
C7519
C3687
D3626
D3627
R3610
C3633
D3602
L3608
L3607
L3606
L3605
C3604
J4301
R189
R188
D3207
C7238
C7239
C7240
C7241
C7242
R7513
Q3605
C7518
C856
12
X7501
IC3611
X3601
C3654
C3686
R3633
B3622 C3650
R3687
R3684
C3611
R3621
R3714
R3713
R3716
Q3619
C3722
C898
W859
Q3606
C7521
R3649
C3643
R3619 C3642
R3718
D3613
C3632
R3651 R3622
IC3605
R3712
Q3613
C7203
IC3201
C3224
C3639
CP3604
R3645
R3631
34
C3637
R3647
X3602
R3697
C3694
R3698 C3693
37
NR7503
NR7504
C3640
R3679
R3680
R3639
R3717
C3723
CP3601
R7201
C3217
R3640
1
R3628
R3632
R3648
D3609
R3652
R3637
C3702
109
R3643 W969
R3644 W970
C3659
C3615
C3634
C3658
C3703
CP3603
R3641
W957
R3627
C3705
J3601
C3638
C3641
Q3620
C3707
73
B3207
C3213
B3612 W1024 B3606
CP3602
R3626
R3625
B3206
B3203
B3202
B3205
B3201
R3224
R3223
Q3205
W860
PRINTED CIRCUIT BOARDS
SCALER (TOP SIDE)
R4304
R4323
B4305
R4315
R4310 R4316
R4309
R4308 B4304
R4305
B4303
C8150
R8105
21
R208
R174
W984
R148
1
W820
76
C117
CP2200
G-6
PRINTED CIRCUIT BOARDS
SCALER (BOTTOM SIDE)
C3690
C3612
C3689
C3655
C3630
D3604
C3605
C3628
C3607 C3624
R3690
C3688
C3656
R3710
C3623
C3622 R3711 R3695
C3721 C3720
C3606
D3600
D3605
R4324
R4319
R4328
R4329
C4351
C4352
C3621
R3709
C3602
W852
C3609
R3692 R3694 R3693
C4358
C4353
C4357
R3607 R3606
R3605
R3688 R3630
D3630
R4333
B3613
C3704
W803
R3654
C2150
C2151
R3653
C3657
C3627
D3629
D3628
IC3602
R3707 R3708 C3645
C3649
R3706
C3713
B3621
C3652
C8109
C8112
C8113
C8110
IC3601
C3708
C3709
B3605 R3689
R3703
R3702
C3710
R3701
C3711
C3620 C3626
C3618
C3625
C3610
C3719
L8102
R8116 R8113
C8128
R8119
C8137
C8129
R8123
R8125
C8144 C8146 R8131
R8129
R8128
R8130
C8147
R8148 R8146
W930
W929
W805
W931
C3706
W839
B7502
C827
C835
C2136
C2131
R845
R844
C7510
C7512
C7516 W975
C7515
C7513
C7514 W872
R7509 W973
R7510
C852 C855
B806
R807
C841 C840
C839
C819
C846
C845 C847
C818
C817 C843 C844
C842
C826
C812 C816
C851
C822
C837 C838 C836
C824
C814 C823
R2111
C2144
C2137
R823
B803
W810
C2105
C7507
C7506
D3209
D3208
R3236
W988
R3216
D3212
R3217
R3222
R3221
C7227
L7201
R3246
R3244
R7207
R7206
C7202
B7202
C7229
C7222 W882
C3215
C3216
C7221
L7202
D807
Q3206
R3228 W1007
R3212
R3211
C3211
C3212
C3222 R3232
C3223
C7508
C887
C888
C884
C813
C894
C889
L7203
C893
B805
W871
B7501 W870
W854 W869
C7502
R178
R109
R107
R7210
R7211
W834
W835
W889
C7201
R209
Q3210
C3204
C3206
C3207
C3205
C3201
C3203
W1013
R137
R193
R192
W1015
R181
R205
R204
R177
R176
R195
W896
W895
W897
R194
Q104 Q106
R8115
R8114
R8145 R8143
L2106 C2145
C2132
C2143
C2138
C2129
R2110
R2108
C2126
C2124
L2102
W987
C113
R106
R105
R160 R161
C107
R133
R132
R136
C123
R131
Q3211
NR7203 NR7204
R3238
R199
W880
R3237
IC7202
C126
R138
C7226
C106
R175
C3219
C3218
C118
C3712
C3651
W1023 W1022 R3634
G-8
G-7
CEF156A
W989
C886
R3245
R158
R198
C104
R102
R140
R104 R103
L2101
W983
C877 C873
IC3203
W830
R117
Q3614
R3681
B3604
W979
C871
B3603
Q3617
R3686 R3683
R3635
R3705 C3653
C3646
W821 W978
R831
R3220
C7218
R116
W980
R200
C7504
C7505
R836
C7511 R7508
R7506 R7512
W974
C7509
C878
R819 R820
C2109
R3209
R3235
R3234
R154
R157
R156
R155
R804
L7502
C853
C820
B802
W1010
C896 R834 R835
C111 C114
NR3602
R821 R826
C870
R822 R828
C872
R829 C879
C875
C897
C895 C821
D808
R2104
W807
NR3601
C3647
W883
W809
W801
W802
NR7506 NR7505
B2101
R2106
Q3621
W971
L2107
IC3609
L4301
W892
C3635
R3704
IC8103
Q8102
C862
C2111
R8118
R817 R818
C2110
C2108
C2113
C2112
R8121
C849
C2125
C2120
R2103
C2116
R2102
Q8103
Q8105 Q8106
R8117
R3699
C3701
R3700
W1012
Q8101
C4350
Q4302
R8120
Q3618
B3602
Q3615
Q3603
C3613
C3614
C3691
C3699
R3629
R3696
Q3607
C3700 C3692
R3678 C3696 C3695
C3697 C3698
IC8104
Q3616
IC4304 IC4305
Q3604
IC3606
R4320
Q4305
W891
C3717
C3718
C3617
C3714
C3608
C3715
C3716
C3619
C3616
R3669
R3617
B3601
R3685
R3608
R3609
PRINTED CIRCUIT BOARDS
DIGITAL (TOP SIDE)
C2506
R2530
R2531 R2522
R2447
R2448
C2471
R2526
C2571
IC2401
C2570
R2525
R2527
C2572
C3407
R3423
R3422
R3414
C3411
W808 D3407
C2451
IC2402
L2401
C3416
A30
B2407
C3412
C3428
C2608
C2611
D3406
D3402
C3420
B3408
C2625
C2621
C2465 C2612
C2542
R2495
B2424
B2423
IC2405
C2466
C3424
R2418 R2417
R2416
C2464
C2507
X2402
B2422
R2498
R2499
C2622
CEF169A
C2537
C2538
R2481
C3423
C3413
R2497
C2509
C2508
R2482
A1
B2426
B2425
B2421
C2487
C2456
C2457
C2450
B2405 R2405
B2401 R2401
X2401
C2490
C2491
C2453
C2454
R2407
C2488
CP2405
L2412
R3430
R3429
C2482
C2483
C2481
R2528
R2410
R2532
L2413
C2485
C2484
C2502
NR2403
NR2405
C2486
C2503
C3432
L3401
R2409
R2529
C2467
R2429
C2504
L2411
C2569
R2524
AK1
L2414
AK30
C2564 C2562
R2520
R2523 R2521 C2561
R2517
IC2403
C3435
R2519
R2518
B2420
NR2401
C2479
R2464
R2484 R2592
R2485 R2593
R3412
R3411
R3410
HS2401
C2563
C2495
C2496
C2494
R2536
C2497
R2537
R2535
C2498
C2478
C2499
C2606
B3406
DIGITAL (BOTTOM SIDE)
8
R2419
R2459
C2
51
3
59
R2458 R2420
R2460
R2457
C2
R2422
R2462
NR2408 NR2409
C2532
C2512
C2514
IC2406
B2408
C2515
C2624
R2421
NR2404
NR2402
NR2407 NR2406
C2522
C2519
R2402
C2448 B2409
R2461
C2461
B2414
B2427
B2413
B2415
C2534
3042B
B2412
B2411
B2406
C2452
R2515 R2508 C2702
C2701
R2441
CP2403
R2538
R2539
C2462
C2513
C2407
C2531
C2517
C2521
C2520
C2404 C2516
C2442
C2433 B2410
C2402
C2403
C2432
C2401 C2460
C2431 C2430
C2582
C2581
C2445
C2429
C2428
C2505
C2426 C2500
C2427
C2425
C2424
C2630
C2609
NR2412 NR2413
R2435 R2437
C2475
C2417
C2416
C2474
C2472
C2412 R2443
C2411
C2470
C2469
C2468
C2444
C2583
C2409
C2443
C2408
C2435
C2434
C2459
R2406
Q2406 Q2403
R2440
B3407
C2455
C2551
R3432
C2605
B3410
Q3407 Q3406
R3433
R2403
R3418
R3419
R3420
D3405
R2404
C2533
C2463
R2414 C2535
C3418 C3421
C3429
R2512 R2509
C3426
R3421
C3419
C3425
R3406
Q3403
IC3402
D3404
R3405
R3401
Q3404
C2559
C2555
B2402
B2419
B2417
D3403
IC3401
IC3403
NR2411 NR2410
R2541
C2449
R2540
R2452
B2404
R2454
C2439
C2418
C2415
C2436
C2414
C2554
C2413
C2597
C2586
C2585
C2447
C2596
C2595
C2584
C2410
C2592
R2470 C2594
C2591
C2406 C2423
C2405
C2458
C2573
C2558
B3402
C3415
Q3405
D3408
G-9
C2560 C2574
C2557 C2576
C2556 C2575
C2553
C2552
B2418
B2416
R3428
R2455
C2473
R2425 C2477 C2476
R2449 C2422
C2421
C2441 C2440
C2590
C2589
C2446
C2602
C2601
C2588
C2587 C2600
C2599
8
7
C2420
43 259
C2419
C2 C
C2438
Q2404
B3401
R3434
Q2407
R2514
R3427
C3410
R3413
C3409
C3408
R2516
Q2401
IC3404
R2534
C3434
C3430
R3424
R3426 R3425
R2533
R2506
IC2404
C3431
CEF169A
CP2404
C2623
G-10
PRINTED CIRCUIT BOARDS
OPERATION
SIDE JACK
SOLDER SIDE
SOLDER SIDE
J4206
J4207
J4209
J4208
C6542
C6543
L4200
B4208
R6504
R6509
R6508
W001 R6505
L4227
CP4200
CEE134A
R6506
B4210
R4493
B4209
SW2205
FILER
SW2201
SOLDER SIDE
F3900
C2209
SW2202
D3900
R2201
SW2204
R2203
FH3901
R2202
W858
W857
FH3900
AS MARKED.
- REPLACE
RISK OF FIRE
SW2203
R2205
CEE133A
CP3900
W856
W855
W860
W859
SW2206
R2206
R2204
CEE131A
D3902
C2204
CP2203
G-11
PH3901
D3901
PH3900
CP3901
G-12
A
B
C
D
E
F
G
H
AV SWITCH2 SCHEMATIC DIAGRAM
8
TR4201
TR4202
W5T29X7.5X19 W5T29X7.5X19
(AV PCB)
FROM/TO POWER
TR4204
TR4205
W5T29X7.5X19 ZCAT2436-1330A
8
TR3805 TR3806
ZCAT2436-1330A
ZCAT2436-1330A
AT+3.3V
AT+5V
TR4206
ZCAT2436-1330A
CD4200
CU28A005
P.CON+9V
GND
L4402
OUT3
3
R4416
1.8
100
0
C4414
470P CH
0
1
5
6
22
100
R4234
100
R4233
5.6K
G
D
S
D
S
5.6K
R4231
G
47P CH
47P CH
C4265
C4264
16V 100 V-S
C4261
20
18
16
NC
SCART3_SW
W929
10
14
SCART_AUDIO_SW13
SDA1
SCL1
12
GND
10
11
DTUNER_POWER 9
GND
DTUNER_SD_H
8
DTUNER_SD_H 7
GND
6
SWITCH_CVBS
GND
5
4
SWITCH_VIDEO_Y 3
R4228
390
GND
R4225
3
STEREO_RESET 15
2
2
SWITCH_VIDEO_C 1
CD4203
2H0T0801
CAUTION: DIGITAL TRANSISTOR
0
23
24
SW
Q4231
KRA103SRTK
CAUTION: DIGITAL TRANSISTOR
0
5.0
DTUNER_TX
SW_AUDIO_L(PC) 17
NC
5.0
330 1/4W
25
NC
W928
1K
R4410
16V 100 V-S
C4252
1.8
R4214
C4260
820
R4409
BUFFER
Q4203
KTC3875S_Y_RTK
26
DTUNER_RX
GND
SW_AUDIO_R(PC) 19
STEREO_RESET
33P CH
NC
B
8.9
2.4
GNP/INV_DET
GND
1.5
4
DTUNER_RESET_L 21
SW_AUDIO_L[PC]
DTUNER_POWER
2.1
1K
C4256
1
10K
0.01 B
C4240
BUFFER
Q4205
KTC3875S_Y_RTK 8.9
R4223
C4247
28
DTV_MUTE_L 27
DTUNER_TX
390
L4203
16V 22 KA
1.5
8.9
BUFFER
Q4206
KTC3875S_Y_RTK
16V 100 V-S
2.1
33uH
820
D_SW_1
L4204
W802
29
DTUNER_H
GND
C4286
390
C4246
DVD/AV3_SW
GND
10P CH
R4256
SW_CVBS
SW_C
3.3
LEVEL SHIFT
Q4208
KTK5132E
3.3
3.9K 1/4W
5.0
D_L1_Vin
R4209
47uH 0305
0.01 B
R4216
6dB
AUDIO_MUTE_L
W852
SW_AUDIO_R[PC]
680
5.3
A2001WV2-6P
1SS133
R4230
23
R4212
SW_Y
NC
DTUNER_H
47uH 0305
3.9K 1/4W
SW_A_L
3.3
Q4210
KTK5132E
3.3
DTUNER_RESET
0.01 B
SW_A_R
5.0
CP4203(CP803)
00_6232_029_006_800+
DTUNER_RX
L4207
C4243
R4210
Vcc
5.0
SCL
47uH 0305
L4206
0.1 B
C4413
W870
9
100
9.0
+
0
R4402 5.0
D4209
SDA
100
R4220
AV SW IC
IC4201
AN15853B-E1
CD4202
CU267901
8
R4219
FROM/TO SCALER
LEVEL SHIFT
UDZS12B
47P CH
FROM/TO IR PASS THROUGH
A
4
3
W869
20
21
22
6
5
6dB
5.4
1
STANDBY_LED
REMOCON_IN
1 B
390
AV1_IN
4.5
7.5
1 B
C4223
IR-THROUGH
C4251
R4213
470P CH
AV1_IN
AV1_A_IN_L
1 B
C4222
UDZS12B
10K
C4206
BIAS
5.4
S1_Y_IN
1 B
C4224
47P CH
AV1_A_IN_L
AV1_A_IN_R
UDZS12B
33
C4456
D4203
470P CH
D4210
4.5
35
470P CH
S1_Y_IN
1 B
C4221
6dB
7.5
4
C4207
5.7
5.4
S1_C_IN
1B
S2_C_IN
5
1 B
24
28
30
4.5
3
UDZS12B
D4208
R4211
D4202
C4239
29
0
CH
C4250
5.7 C4203
31
47P CH
C4208
470P CH
SCL
SDA
SW_AUDIO_R[JACK]
SW_AUDIO_L[JACK]
STEREO_RESET
SW_AUDIO_L[PC]
SW_AUDIO_R[PC]
25
7.5
8
0
1 B
C4218
AV1_A_IN_R
H-1
DTUNER_RESET
DTUNER_TX
AUDIO_MUTE_L
DTUNER_POWER
DTUNER_SD_H
DTUNER_RX
TUNER_VIDEO
DTUNER_CVBS
CH
27
10
AV2_IN
1B
4.7
2
220 1/4W
IR-THROUGH
2.2 B
26
GND
5.4
1 B
C4217
47P CH
C4225
R4401
REMOCON IN
Vin1
C4416
47P
0
7
S1_C_IN
47P
3.5
SCL
7.5
YUV1_A_IN_L
C4227
47uH 0305
L4202
19
18
14
SDA
7.5
YUV1_A_IN_R
UDZS12B
4.7
SIDE_Y_IN
1 B
470P CH
AV2_IN
1
SW1
6
FROM/TO TUNER
SIDE_A_IN_R
32
47P CH
1 B
D4211
C4238
3.5
9
C4205
YUV1_A_IN_L
2
1
SW_CVBS
0
S_SW_2
12
470P CH
C4229
4.7
5.4
SIDE_C_IN
1 B
C4220
GND
2
SW_YUV_PR
SW_YUV_PB
SW_YUV_Y
C4415
34
1 B
C4215
SIDE/DVD_Y
3
3
FROM/TO STEREO
C4242
S2_Y_IN
YUV2_A_IN_R
4.6 C4202
11
C4216
YUV1_A_IN_R
4.7
0
S_SW_1
C4228
Vref
4.5
1 B
C4233
YUV2_A_IN_L
4.5 C4201
15
SIDE_A_IN_L
47P CH
SIDE/DVD_C
4
GND
SIDE_A_IN_L
36
4.7
TUNER_V
470P CH
C4214
S_SW_1
1
V.OUT
PC/YUV Rch SW
IC4402
MM1501XNRE
17
4.5
SIDE_A_IN_R
C4226
C4210
P.ON LED
4
FROM/TO TUNER/OUT JACK
0
C4469
3.3
16
4.7
UDZS12B SIDE_V_IN
25V 10 KA
C4231
25V 10 KA
STANDBY LED
AT+5V
C4412
DTUNER_H
13
470P CH
SIDE_A_IN_R
C4230
SIDE_A_IN_L
5
5.0
25V 100 YK
1 B
6
SIDE/DTUNER_V_IN
Vin2
Vcc
2.2 B
2
10 V-S
0
D4212
C4232
CP4202_1 (CP2251)
1K
R4405
1K
5
6
NC
100
9.0
BUFFER
Q4401
KTA1504S_Y_RTK
16V
IN3A
2.0
1M
IN3B
NC
7
GND3
R4417
V-S
C4211
47P CH
C4213
2
7
FROM/TO AV JACK2
SIDE/DTUNER_V_IN
3
5
W865
SIDE/DVD_C
C4471
S2_Y_IN
S_SW_2
YUV2_A_IN_L
STANDBY_LED
4
6
SIDE_V_IN
SIDE_A_IN_R
BUFFER
Q4409
KTA1504S_Y_RTK
S2_C_IN
REMOCON_IN
SIDE_S_SW
7
SIDE_S_C
GND
TUNER_VIDEO
FROM/TO TUNER/OUT JACK
8
SIDE_S_Y
GND
2.5
YUV2_A_IN_R
5
16V100 YK
10 V-S
1K
0
BUFFER
Q4410
KTA1504S_Y_RTK
SIDE_S_L
SIDE_A_IN_L
R4412
16V 10
10
C4403
DTUNER_Y
100
4
V-S
16V47
B
C4406
V-S
9
16V 10
C4407
IN2A
1.8
W867
SIDE/DVD_Y
DTUNER_CVBS
C4402
YUV1/YUV2_PB
R4418
16V
OUT2
2
CTL
OUT1
R4411
16
15
14
13
GND2
1M
6
0305
DTUNER_H
V+
NC
1M
YUV1/YUV2_Y
YUV1/YUV2_PB
YUV1/YUV2_PR
YUV1_A_IN_L
YUV1_A_IN_R
YUV2_A_IN_L
YUV2_A_IN_R
S_SW_1
S_SW_2
S1_Y_IN
S1_C_IN
S2_Y_IN
S2_C_IN
AV1_IN
AV2_IN
AV1_A_IN_L
AV1_A_IN_R
V-S
C4405
47uH
FROM/TO AV JACK
IN2B
12
16V 10
L4401
GND1
11
C4404
DTUNER_PB
0.01
IR-THROUGH
1M
V-S
IN1B
IN1A
1M
16V 10
FROM/TO IR PASS THROUGH
R4406 R4403
C4401
YUV1/YUV2_PR
2.5
CP4201 (CP4200)
A2001WV2-8P
SIDE_S_SW
8
DTUNER_PR
1
COMPONENT1/2 YUV SW
IC4401
NJM2584AM(TE1)
R4408 R4407
7
FROM/TO OPERATION/SIDE JACK/
FILTER/POWER SWITCH
0305
47uH
1M
DTUNER_Y
DTUNER_PB
C4408
FROM/TO TUNER
R4419
YUV1/YUV2_Y
DTUNER_PR
R4404
P.CON+5V
SW
Q4233
KRC102SRTK
NOTE:THE DC VOLTAGE AT EACH PART WAS MEASURED
WITH THE DIGITAL TESTER WHEN THE COLOR BROADCAST
WAS RECEIVED IN GOOD CONDITION AND PICTURE IS NORMAL.
NOTE: THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME
OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE
1
PCBD20
CMF083
GND
B
C
D
E
F
G
H
H-2
A
B
C
D
E
F
G
H
TUNER/OUT JACK SCHEMATIC DIAGRAM
8
8
(AV PCB)
FROM/TO AV JACK
SW_YUV1/2
EXT_MUTE
FROM/TO AV SWITCH2
7
AT+5V
DTUNER_SPDIF
CD4204
2H0U0802
AT+3.3V
W834
7
SIDE_S_SW
REMOCON_IN
STANDBY_LED
SW_YUV_Y
SW_YUV_PB
SW_YUV_PR
FROM/TO SCALER
MUTE
Q4402
KRA103SRTK
FROM/TO AV JACK2
4.9
4.7K
REMOCON_IN
4.9
R4420
0
4.9
6
AFT
LEVEL SHIFT
Q4403
KRC102SRTK
W876
FROM/TO TUNER
00_6232_030_006_800+
STANDBY_LED
SW_SPDIF
EXT_MUTE
CP4204 (CP802)
4.7K
R4415
SW_SPDIF
0
AUDIO_MUTE
SW_YUV_PB
SW_YUV_Y
SW_YUV_PR
FROM/TO SOUND AMP/HEADPHONE AMP
AUDIO_MUTE
POWER_ON-H
26
GND
23
SCART1_B
GND
22
6
21
SCART1_G
20
GND
19
SCART1_R
18
GND
15
NC
SCART1_Y
14
NC
SCART2_SW
13
NC
PSU_ACD/P.FAIL
POWER_ON-H
NC
RLY_ON/LCD-H
10
9
8
LCDON
DVB_FAN_ON-H 7
LCD-H/PDP_RLY 6
SIDE_S_SW
S_DET
NC
SW_YUV1/2
NC
PSU_5VD/DSR/LIGHT_CTL
5
SC2 CVBS_OUT-H 12
11
POWER_FAIL
POWER_ON-H
AFT_1
AFT_1
VS_ON/LCDON
PSU_ACD/P.FAIL
PSU_5VD/DSR/LIGHT_CTL
VS_ON/LCDON
RLY_ON/LCD-H
POWER_ON-H
AT+5V
AT+3.3V
GND
27
17
GND
AFT_2/DTV_CVBS 16
AFT_2
FROM/TO POWER
28
AUDIO_MUTE 25
EXT_MUTE-H 24
AFT_2
5
29
AFT
HP_MUTE
0
AFT_1
30
REMOCON IN
NC
DTUNER_SPDIF
AFT
STANDBY LED
5
SCART1_SW
4
SW_YUV1/2
HP_IN
3
2
LIGHT CTL/PSU_5VD1
4
4
3
3
2
2
NOTE:THE DC VOLTAGE AT EACH PART WAS MEASURED
WITH THE DIGITAL TESTER WHEN THE COLOR BROADCAST
WAS RECEIVED IN GOOD CONDITION AND PICTURE IS NORMAL.
NOTE: THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME
OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE
CAUTION: DIGITAL TRANSISTOR
CAUTION: DIGITAL TRANSISTOR
1
A
H-3
1
PCBD20
CMF083
B
C
D
E
F
G
H
H-4
A
B
C
D
E
F
G
H
AV JACK SCHEMATIC DIAGRAM
8
8
(AV PCB)
FROM/TO POWER
GND
GND
L4403
P.CON+5V
P.CON+5V
100 YK
16V
C4464
10uH 0305
7
7
B4220
5
BLM18BB600SN1
YUV1/YUV2_PB
6
V+
CTL
IN2A
GND3
15
0
14
3.0
13
5.1
12
3.0
11
3.0
10
0
E
1
6
H1 H2
8
9
H2
100P CH
75
C4290
75
R4260
100P CH
R4259
75
C4284
C4278
100P CH
R4255
100P CH
75
C4276
75
R4242
100P CH
R4262
6
RED
RED
5
L4215
L
YUV1_A_IN_L
E
1
2
E
RED
7
4
RED
8
22uH
WHITE
4
6
L4217
0.001 B
0.001 B
C4289
C4287
NC H2 NC H1
YUV2_A_IN_R
5
22uH
YUV1_A_IN_L
YUV2_A_IN_L
H1 H2
L4216
L
R
YUV1_A_IN_R
WHITE
3
0.001 B
C4285
C4282
22uH
YUV2_A_IN_L
SW_YUV1/2
AUDIO_IN 4/5
J4204
YKC21-4613N
22uH
L4213
R
YUV1_A_IN_R
0.001 B
KA
1M
25V 10
KA
25V 10
C4452
1M
KA
C4451
KA
BLUE
9
SW_YUV1/2
4
BLM18BB600SN1
BLM18BB600SN1
V
AV5_V
BLM18BB600SN1
R4297 R4294
1M
25V 10
FROM/TO TUNER/OUT JACK
25V 10
C4450
1M
B4205
B4211
2.6
C4453
R4295 R4296
U
BLUE
IN3A
IN2B
16
3.0
AV5_U
B4204
IN3B
5
1M
0 NC 2.6
7
8
NC
GND2
1.9
R4299
KA
NC
3
2.3
OUT3
0
4
OUT2
1M
2.3
GND1
1
0 NC
2
IN1B
5
KA
3.0
25V 10
IN1A
COMPONENT SW
IC4204
NJM2584AM(TE1)
25V 10
R4298
OUT1
C4448
Y
75
C4258
C4449
YUV1_A_IN_L
YUV1_A_IN_R
YUV2_A_IN_L
YUV2_A_IN_R
S_SW_1
S_SW_2
S1_Y_IN
S1_C_IN
S2_Y_IN
S2_C_IN
AV1_IN
AV2_IN
AV1_A_IN_L
AV1_A_IN_R
AV5_Y
C4454
YUV1/YUV2_PR
100P CH
R4240
6
GREEN
GREEN
E
BLM18BB600SN1
B4219
4
V
BLM18BB600SN1
E
AV4_V
B4218
2
U
3
Y
AV4_U
7
YUV1/YUV2_Y
AV4_Y
H1 H2
FROM/TO AV SWITCH2
H1
CS_IN 4/5
J4211
YKC21-4720N
YUV2_A_IN_R
S_SW_1
R4261
S_SW_1
1K
R4250
1
R4252
S2_Y_IN
2
75
NOTE: THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME
OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE
1
A
H-5
B
C
L
BLM18BB600SN1L4219
AV2_A_IN_R
R
22uH
6
11 5
12
E
13
E
RED
RED
L4218
22uH
470P CH
75
C4283
WHITE
2
AV2_A_IN_L
C4272
AV2_A_IN_R
WHITE
B4217
V
0.001 B
R4249
AV2_A_IN_L
BLM18BB600SN1
AV2_IN
0.001 B
C4275
AV2_IN
B4216 BLM18BB600SN1
Y
R4254
FROM/TO STEREO
B4215
C
100P CH
S2_Y_IN
75
C4296
S2_C_IN
100P CH
C4297
S2_C_IN
YELLOW
E
22uH
MTZJ8.2B-EIC
YELLOW
NC H1
L4214
NOTE:THE DC VOLTAGE AT EACH PART WAS MEASURED
WITH THE DIGITAL TESTER WHEN THE COLOR BROADCAST
WAS RECEIVED IN GOOD CONDITION AND PICTURE IS NORMAL.
D
E
3
D4207
19
1K
16
22uH
H1 H2
8
L4212
R4251
S_SW_2
4 3
BLM18BB600SN1
H1 H2
75
C4277
C4271
S_SW_2
D4206
MTZJ8.2B-EIC
2
R
B4214
7
AV1_A_IN_R
BLM18BB600SN1
10 9
AV1_A_IN_R
470P CH
L
0.001 B
R4248
V
AV1_A_IN_L
AV1_IN
0.001 B
C4274
AV1_IN
AV1_A_IN_L
B4222
21 20 23 22 17 18 14 15
75
3
BLM18BB600SN1
Y
R4253
INPUT 1/2
J4205
SAV-12CP-01Z5
NC H1
S1_Y_IN
B4221
C
100P CH
S1_Y_IN
75
C4455
S1_C_IN
100P CH
C4288
S1_C_IN
1
PCBD20
CMF083
F
G
H
H-6
A
B
C
D
E
F
G
H
STEREO SCHEMATIC DIAGRAM
8
(AV PCB)
FROM/TO POWER
8
W839
AT+5V
FROM/TO TUNER
B901
10K
R915
10K
R914
P.CON+5V
L901
1K
5.0
R913
C906
10V 220 YK
0.6
0
I2SSD0_OUTA
BLM18BB600SN1
GND
B902
I2SWS_OUTA
BLM18BB600SN1
4.9
SW
Q902
SW
0
Q901
KTC3875S_Y_RTK
KTC3875S_Y_RTK
0.6
B903
I2SSCLK_OUTA
BLM18BB600SN1
I2SSD0_IN
I2SWS_IN
I2SSCLK_IN
P.CON+8V
SIF
R906
10uH 0305
R905
7
7
100
100
L903
22P CH
R901
0 NC
4.4
NC
2
GND
1
C903
1
B
SP_AUDIO_OUT_R
1
B
5
71
C957
8P CH
70
C955
1.9
56P CH
69
2.6
68
C953
67
C954
66
56P CH
63
64
65
NC
AVSS
3
4.9
NC
NC
AVSS
MONO_IN
VREFTOP
AVSUP
62
0
C956
8P CH
4.9
59
60
61
0 NC4.8 NC 0
HDMI_I2SSDO
HDMI_I2SWS
GND
C909
0
X901
NC 18.432MHz
2.4
72
73
C959
0
NC
2.4 56P CH
SIF
4
0 NC 0 NC
C946
C944
0.1 B
C952
0.33 B
C940
0.33 B
C942
0.33 B
C934
ANA_IN-
65 AVSUP
55
56
57
58
0 3.8 3.8 2.6
0.33 B
0.33 B
SW_A_IN_L
(AV1/YUV/SIDE)
SW_A_IN_R
ASG1
SW2_A_IN_L
(PC/HDMI/DVI)
SW2_A_IN_R
ASG2
NC
0.1 B
ANA_IN2+
C950
50V 10 YK
STEREO_RESET
0.0015 B
C936
50V 10 YK
52
53
54
0 3.8 3.8
0.33 B
C918
FROM/TO AV SWITCH2
C920
46
47
48
49
50
51
0 NC 3.8 NC3.8 NC 0 6.5 6.5
C927
470P CH
44
45
0 3.7
50V 3.3 KA
C917
AHVSS
43
0
NC
4
C926
AHVSS
41
42
0 NC 0 NC
50V10 YK
AGNDC
AHVSUP
7.1
(AV2)
AV2_A_IN_R
CAPL_A
40
C914
40 CAPL_M
8.0
39
50V 10 YK
VariOut_L
C963
7.1
38
16V 22 KANP
AV2_A_IN_L
C915 100
AUDIO_JACK_OUT_L
HDMI_I2SWS
SP_AUDIO_OUT_L
0.0022 B
0
NC
0
NC
C919
VariOut_R
HDMI_I2SSCK/MCKL4
HDMI_I2SSDO
BLM18BD102SN1
FROM/TO SOUND AMP/HEADPHONE AMP
0.0022 B
0
NC
1.9
TESTEN
ASG4
R916
3.8
XTAL_OUT
XTAL_IN
C962
3.8
100
VREF1
TP
STEREO IC
IC904
MSP4440G-QA-C13-100
SW1_A_IN_L
(DVD)
SW_A_IN_R
R904
SC2_OUT_L
37
16V 22 KANP
33
C916
AUDIO_JACK_OUT_R
SC2_OUT_R
34
FROM/TO AV JACK2
NC
NC
35
5
D_CTR_I/O_1
AUDIO_CL_OUT
36
0
NC
3.8
NC
0
79 ADR_SEL
B906
6
C958
NC
0
NC
26 VREF2
W894
HDMI_I2SSCK
B905
CD901
CU247001
W856
77
30
DACM_SUB
0
NC
32
0
NC
L904
NC
80
78
0
NC
76
79
0
NC
31
0
NC
80 STANDBYQ
BLM18BD102SN1
BLM18BD102SN1
4.9
D_CTR_I/O_2
25 NC
B904
W893
R903 33
0.1
13
33
1
I2C_CL
I2C_DA
I2S_CL
I2S_WS
I2S_DA_OUT
I2S_DA_IN1
ADR_DA
ADR_WS
DVSUP
ADR_CL
DVSUP
DVSS
DVSUP
DVSS
17
DVSS
NC
18
0 NC 0 NC 0 NC0.2 5.0 5.0 5.0
0 4.9 4.9 4.9
1.7 2.5
14
13
12
11
10
9
8
7
4
3
2
6
5
0
15
75
NC
19
0
16
74
SPOUT_L
20
0 NC0.2 NC
I2S_DA_IN2
26
27
SPOUT_R
28
0.1
29
12
0
I2S_CL3
0
6
21
RESETQ
NC
22
I2S_DA_IN3
25
0
NC
23
NC
24
0
4.9
I2S_WS3
0 NC 0 NC 0
R902
W892
W857
D901
MTZJ5.6B-EIC
33
CP901(CP3602)
A2001WV2-4P
10uH 0305
22P CH
C949
220P CH
C948
C943
470P CH
C945
C941
0.0015 B
C933
6.3V 1000 YK
C904
16V 22 V-S
C922
0.1 B
FROM/TO HDMI MICON2
10uH 0305
0.0015 B
470P CH
C951
50V 10 YK
S801X
SCL
SDA
SW_AUDIO_L[PC]
3
SW_AUDIO_R[PC]
3
SW_AUDIO_L[JACK]
SW_AUDIO_R[JACK]
FROM/TO AV JACK
2
2
AV2_A_IN_L
AV2_A_IN_R
NOTE: THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME
OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE
NOTE:THE DC VOLTAGE AT EACH PART WAS MEASURED
WITH THE DIGITAL TESTER WHEN THE COLOR BROADCAST
WAS RECEIVED IN GOOD CONDITION AND PICTURE IS NORMAL.
PCBD20
CMF083
1
1
A
H-7
B
C
D
E
F
G
H
H-8
A
B
C
D
E
F
G
H
SOUND AMP/HEADPHONE AMP SCHEMATIC DIAGRAM
8
8
(AV PCB)
24.0
36
1
+5VGEN
CPUMP
0
DCAP1
PGND1
35
2
DCAP2
3
0
VDDA
33
VD5
NC
OUTP2
OAOUT2
6.0
F
B
0.1
C354
C352
1/2W 0.47
R320
10
0.47
B 0.47
C349
C348
B
1/2W
B
C355
R321
10
1
NC
2
2
SP OUT R+
1
3
SP301
EAS12D175B
4 OHM 10W
SP303
22
EAS5PH134C
NC
0
AGND3
PGND2
SLEEP
FAULT
0
0
W907
NC
5
470P CH
0
C362
21
0
NC
R324
AT+5V
47K
6
SPEAKER
TR302
W5T29X7.5X19
C359
470K
CD301
CU13A301
SPEAKER
NC
470P CH
0.1 B
2
(R)
470P CH C363
S801Y
SW
Q300
0
KTC3875S_Y_RTK
DGND
SP302
EAS12D175B
7
C358
10K
C323
3.0
L303
NC
20
R311
0.1 B
18
GND
SOUND_GND
SOUND+B
BIASCAP
C332 2.5
R338
0
INV2
1
CP301 A2502WV2-3P
SP OUT R3
6
470P CH
22K
SP OUT L-
0
19
50V 1 KANP
1K
FROM/TO POWER
5
2.5
15
R315
C319
16
R302
17
2
5
SPEAKER
10uH7313N
0
NC
23
R319 2.5
22K
16V 1000 YK
24
NC
(L)
CD303
CP303 A2502WV2-2P CU12A501
2
1
SP OUT L+
0.1
VDD2
0
C353
MUTE
25
W886
0.1 B
C342
11.0
0
10uH7313N
C350
VDD2
26
INV1
C341
0.47 F
22K
12
50V 1 KANP
13
1K
11
C320
SP_AUDIO_OUT_L
11.0
0.47 B
OUTM2
27
OAOUT1
2.5
TR301
W5T29X7.5X19
10uH7313N
L302
6.0
10
R314
L301
C351
OUTM1
28
9
V5A
D302
31
6
6.0
16V 1000 YK
D303
VDD1
29
AGND2
22K
R304
C339
0.1
B
C340
10uH7313N
SP304
EAS5PH134C
4 OHM 10W
4
L300
30
VDD1
14
3
OVERLOADB
5.5
R318 2.5
SP_AUDIO_OUT_R
OUTP1
11.0
8
0.1 B
C331
FROM/TO STEREO
REF
11.0
0
6
NC
6.0
7
0
NC
SPEAKER
0.47 B
NC
32
5
AGND1
0
8.2K
+-1%
7
B
0
0
390P CH
R317
C338
0.1
EC31QS04 EC31QS04
0.1 B
C326
4
5.5
C301
NC
11.0
D304
7
NC
34
14.0
D305
0.1 B
C328
23.0
C337
50V 1 KANP
EC31QS04 EC31QS04
0.1
C324
B
SOUND AMP
IC301TA2024-ASE
5.5
HS300
763WAAA066
HS78
NC
C304
0.1 B
D306
FROM/TO TUNER/OUT JACK
4
RB520S-30-TE61
4
POWER_ON-H
C364
AUDIO_MUTE
3
1K
4.8
0
0
3
0
4.8
R325
C365
6.3V 220 V-S
4.7K
R323
4.7K
R322
6.3V 220 V-S
SW
Q302
KTC3875S_Y_RTK
0
SW
Q301
KTC3875S_Y_RTK
2
2
W910
1
THESE PARTS MARKED BY
CAUTION:SINCE
CRITICAL FOR SAFETY,USE ONES
DESCRIBED IN PARTS LIST ONLY
A
H-9
B
W911
ARE
PIECES REPAREES PAR UN
ETANT
ATTENTION:LES
DANGEREUSES AN POINT DE VUE SECURITE
NOTE: THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME
OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE
N’UTILISER QUE CELLS DECRITES
DANS LA NOMENCLATURE DES PIECES
C
D
E
1
NOTE:THE DC VOLTAGE AT EACH PART WAS MEASURED
WITH THE DIGITAL TESTER WHEN THE COLOR BROADCAST
WAS RECEIVED IN GOOD CONDITION AND PICTURE IS NORMAL.
F
PCBD20
CMF083
G
H
H-10
A
B
C
D
E
F
G
POWER SCHEMATIC DIAGRAM
8
L3811
(AV PCB)
8
R3849
TSL0808
22uH
H
1
3W
D3811
D3812
EC31QS04 EC31QS04
D3807 D3806
CH
150P
0
13
0
12
CVCC COSC
0
11
NC
17.8
10
NC
NC
CP3
FROM/TO IR PASS THROUGH
CP1
CP1
1
2
9.4
5.1
C3829
0.22
MMTS
C3830
0.22
MMTS
GND
CP2
CP2
3
4
5
0
17.0
CREG COUT
6
9.5
C3832
2
Vout
3
4
0
4
D3808
D3809
EC31QS04
5
3.8
1.3
P.CON+5V
GND
FROM/TO AV SWITCH2
R3857
EC31QS04
AT+5V
AT+3.3V
P.CON+9V
330
+-1%
HS6S
HS3808
763WAAA070
P.CON+5V
GND
C3804
C3805
R3826
100K
33K
R3827
CD3804
CU672301
3
R3824
R3825
100K
+-1%
6.8K
+-1%
NOTE:THE DC VOLTAGE AT EACH PART WAS MEASURED
WITH THE DIGITAL TESTER WHEN THE COLOR BROADCAST
WAS RECEIVED IN GOOD CONDITION AND PICTURE IS NORMAL.
A
B
G
THESE PARTS MARKED BY
CAUTION:SINCE
CRITICAL FOR SAFETY,USE ONES
DESCRIBED IN PARTS LIST ONLY
C
ARE
P.CON+9V
10uH7313N
AT+3.3V
W836
GND
10
R3828
1.2K
R3832
C3823
35V1000 FM
B
C3822
P.CON+3.8V
23
23 DRIVER
R3830
1.2K
Q3807
2SA1036K
0
23
R3833
PIECES REPAREES PAR UN
ETANT
ATTENTION:LES
DANGEREUSES AN POINT DE VUE SECURITE
10
C3819
0.1
DC-DC CONVERTER
IC3803
BD9300FV-E2
L3808
24 DRIVER
Q3806
KTC3875S_Y_RTK
23
6.8uH SBC4-6R8-452
NOTE: THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME
OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE
W945
AT+5V
1
P.CON+9V
2
P.CON+5V
3
AT+3.3V
4
P.CON+3.8V
5
P.CON+3.8V
6
GND
7
GND
8
GND
3
9
P.CON+5V
10
AT+5V
11
D3803
SBR100-10J-CBC11
2
HS3801
763WAAA070
HS6S
FROM/TO SOUND AMP/HEADPHONE AMP
AT+5V
GND
SOUND+B
SOUND_GND
CAUTION: DIGITAL TRANSISTOR
CAUTION: DIGITAL TRANSISTOR
1
N’UTILISER QUE CELLS DECRITES
DANS LA NOMENCLATURE DES PIECES
D
CP3807(CP3201)
A2001WV2-11P
P.CON+12V
P.CON+12V
23
0.047 B
L3805
22K
C3817
R3820 50V 4.7 YK
R3821
CD3801
CU641802
430P CH
SOUND GND
DTC RT CT FB OUT NC GND
1 2 3 4 5 6 7
1.5 1.0 2.0 2.0 26 NC 0
R3823
SOUND GND
4
0.7
0.7
10K
C3821
3
0
SW
Q3802
KRC102SRTK0
15K +-1%
2
30V or 24V
0
SW
Q3805
KRC102SRTK
0
33K
R3822
2
SW
Q3801
0
DTA124EKA
5
0
C3816
CP3801
A2501WV2-4P
30V or 24V
1
5
0
5
1.2 1.2 1.2 2.5 16 0 32
14 13 12 11 10 9 8
NON INV
CTL SCPVCC
VREF
1/2VRE
0.1 B
4.7K
FROM/TO PDP POWER MODULE
SW
Q3804
DTA124EKA
W821
4.7K
R3803
24
R3808
6.8uH
SBC4-6R8-452
Q3808
2SJ650
CHOPER 11
25V 820 FM
R3806
C3825
47K
C3826
R3802
25V 820 FM
NC/POWER_ON_H NC
FROM/TO REGULATOR
500V 560P B
5VD/LIGHT_CTL
7
L3809
C3849
6
CD3807
CU2B3901
0.0056 B
D
VS ON/LCDON
C3839
AT+5V
22uH TSL0808
2
5
L3804
S
GND
1
5VST_BY/AT+5V
4
3
RLY ON/LCD-H
3
220K
47K
1K
2
R3805
R3801
PSU_ACD/P.FAIL
PSU_5VD/DSR/LIGHT_CTL
VS_ON/LCDON
RLY_ON/LCD-H
POWER_ON-H
6.3V 1000
YK
CP3804
A2501WV2-7P
ACD/P.FAIL
1
4
FROM/TO TUNER/OUT JACK
B
0.001
FROM/TO PDP POWER MODULE
5
FROM/TO AV JACK
ADJ
+-1%
GND
1.8K
1
3
R3834 R3831
C3827
GND
Vcc
R3858
4
2.1
W842
4
H-11
3
0
3.5
FROM/TO SOUND AMP/HEADPHONE
1
2
CTL
1K
1
5.0
CD3803
CU6C1701
GND
W890
NC
OUT
10V 100 YK
R3856
12 NC/INVERTER_DET
IN
NC
C3848
NC/ST_BY_H
F
11
GND
C3847
GND
1
10
AT+5V
R3855
GND
P.CON+5V
REGULATOR
IC3804
PQ070XF01SZH
100
9
22uH TSL0808
1H3-E
REG +3.8V
BA7810T-V5
15K
12VSC
22K
12VSC
8
P.CON+8V
IC3808
R3835
22K
7
L3803
C3806
GND
100P CH
GND
6
6
AT+5V
AT+3.3V
GND
FROM/TO STEREO
C3802
5
MMTS
FROM/TO TUNER/OUT JACK
D3804
16V 1000 FM
GND
C3801
5VSC
4
0.22
GND
30.6
16V 1000 FM
5VSC
3
0.22
MMTS
C3833
AT+5V
7
30.9
L3802
10uH TSL0808
10V 100 YK
5
2
CP3
50V 4.7 V-S
CP3803 (CP510)
A2501WV2-12P
5VSC
1
P.CON+5V
GND
C3834
C3828
FROM/TO TUNER/OUT JACK
8
P.CON+9V
0.01
6
7
FROM/TO AV JACK2
33.7
9
V-S
D3805
4.2
14
GND
0.22 MMTS
50V 4.7
C3837
GND
P.CON32V REG
1H3-E
IC3805
LA7995M-TLM
2
5.0
0.22 MMTS
C3836
B
9VSC
C3803
1
16V 1000 FM
L3810
CP3802 (CP509)
A2501WV2-2P
10uH TSL0808
22uH TSL0808
CD3802
CU622201
7
C3831
FROM/TO PDP POWER MODULE
UNREG+4V
UNREG+5V
P.CON+32V
EC31QS04EC31QS04
C3835
L3801
FROM/TO TUNER
PCBD20
CMF083
E
F
G
H
H-12
A
B
C
D
E
F
G
H
AV JACK2 SCHEMATIC DIAGRAM
8
8
(AV PCB)
7
7
V
E
BLM18BB600SN1
L
R
6
1
75
4
B4225
H1
R4263
5
C4279
16V 470 YK
BUFFER
Q4201
KTA1504S_Y_RTK
E
0
0
SW_CVBS
220
1/2W
10K
33
4.5
CVBS/AUDIO OUT
J4201_1
AV3-13P2-11S1
H2
R4241
MUTE SW
Q4211
KTA1504S_Y_RTK
3
0
0
R4245
1K
C4273
0
8.8
0
H1
2
47K
R4246
MTZJ6.8B-EIC
0.3
MUTE SW
Q4200
KTA1504S_Y_RTK
1K
FROM/TO AV SWITCH2
D4205
1K
R4247
R4244
R4239
16V 100 YK
100uH 0305
R4243
L4211
6
FROM/TO STEREO
R4235
R4237
R4236
270
100
L4220
R4238
22uH
0.3
R4232
0
330
R4229
0.3
0
0
MUTE
Q4207
KTC3875S_Y_RTK
5
0
C4300
330
MUTE
Q4209
KTC3875S_Y_RTK
C4301
5
L4221
22uH
270
0.001 B
100
AUDIO_JACK_OUT_R
0.001 B
AUDIO_JACK_OUT_L
4
4
FROM/TO POWER
P.CON+9V
P.CON+5V
GND
FROM/TO TUNER/OUT JACK
OS4202
TOTX177
EXT_MUTE
3
R4461
SW_SPDIF
68
MMZ1608R102CT
C4461
0.1 F
C4462
B4461
6.3V 47 KA
0.1 B
D AUDIO DRIVER
Q4202
KTC3875S_Y_RTK
1.6
1.5K
VCC
1
GND
BLM18BB600SN1
E
B4202
0.1 B
H
C4234
2
R4206
4.9
1.5K
C4266 R4208
IN
2
COAXIAL JACK
J4202
AVG-2-13
L4201
100uH 0305
3
1
3
1.2
A
B
R4203
100K
R4205
C
2
68
220
3.3K
0.022 B
R4207
C4237
NOTE: THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME
OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE
1
H-13
16V100 YK
C4236
R4204
2
NOTE:THE DC VOLTAGE AT EACH PART WAS MEASURED
WITH THE DIGITAL TESTER WHEN THE COLOR BROADCAST
WAS RECEIVED IN GOOD CONDITION AND PICTURE IS NORMAL.
D
E
PCBD20
CMF083
F
G
1
H
H-14
A
B
C
D
E
F
G
H
IR PASS SCHEMATIC DIAGRAM
(AV PCB)
8
8
(REMOCON PCB)
R2253
7
680K
1
IR-THROUGH
2
REMOCON IN
3
GND
4
AT+5V
5
STANDBY LED
6
C2255
25V 10 KA
220K
D2252
1SS133
12K
R2259
CP2251(CP4202_1)
A2001WR2-6P
1K
FROM/TO AV SWITCH2
B
R2255
390K
R2257
W889
1
W917
PIN PHOTO DIODE
Q2251
HPI6FGR4F2 0.5
C2256
3.5
5
R2254
R2256
W919
BUFFER 5.2
Q2252
KTC3875S_Y_RTK
2.8
6
7
270
6
1 Vout
P.ON LED
2 GND
R2252
3 B+
47 1/4W
KA
C2252
STANDBY/POWER
D2251
LTL-1BEFJ-002A
5
6.3V 100
G
5
R
OS2251
ROM-V338TAO
W848
PCBDA0
CEF179
4
4
L2275
47uH
1
0
R2275
0.01 B
3
3
0
220K
C2276
16V 47 YK
12K
R2276
150
B
FROM/TO POWER
AT+5V
0.1
C2277
or BA10358F-E2
R2279
4
0
1.2K
IR-THROUGH
10K
B
220P
2
+
+
6
-VS
0.2
5
B
220K
0.01
0.01 B
R2280
C2280
0.3
C2279
5
SW
Q2275
0
KTC3875S_Y_RTK
50V 1 KA
C2281
220
5
FROM/TO AV SWITCH2
C2275
R2277
0.2
10K
R2282
R2284
1SS355
SW
Q2276 0
2SA2048
C2278
1
0.1
8
5.2
7
0.3
2.7K
C2282
16V 47 YK
R2285
R2283
R2281
D2275
22
R2288
5
330
56
R2289
CH
BLM18BB600SN1
C2283
B2271
100P
IR PASS THROUGH
J2275
MSJ-035-12A_PC
L
2
R
3
R2286
5
0.4
2.7K
1
R2287
SW
5
Q2277
KTA1504S_Y_RTK
3
R2278
NJM4580V(TE1)
+VS
12K
OPE AMP
IC2275
GND
2
2
NOTE: THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME
OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE
NOTE:THE DC VOLTAGE AT EACH PART WAS MEASURED
WITH THE DIGITAL TESTER WHEN THE COLOR BROADCAST
WAS RECEIVED IN GOOD CONDITION AND PICTURE IS NORMAL.
1
A
H-15
1
PCBD20
CMF083
B
C
D
E
F
G
H
H-16
A
B
C
D
E
F
G
H
TUNER SCHEMATIC DIAGRAM
8
8
(AV PCB)
4
9
Y OUT
10
U OUT
11
GND
12
GND
13
V OUT
14
GND
15
GND
16
CVBS OUT
17
AUDIO MUTE-L
18
SD-H
19
AFT_1
20
AFT_2
3
DTV POWER
3
TX (X240)
4
RX (X240)
5
SPDIF OUT
6
2
24
20 IF_OUT 2
W902
W901
W900
W899
W898
W903
19 IF_OUT 1
18 IF AGC
R5815
390K
0
0.5
2.5
75
0.0022 B
0
R5816
R5813
2.7K
0.5
C5814
1.8
R5814
0.4
IF AMP Q5804
2SC3841-T1B_T63
1K
0
R5810
4.7K
R5809
8.2K
0.6
IF AMP Q5805
2SC3841-T1B_T63
5
12K
15K
R5807
R5808
R5812
12K
100uH
0305
R5811
4.7K
FROM/TO AV SWITCH2
DTUNER_Y
TUNER_VIDEO
DTUNER_Y
DTUNER_PB
DTUNER_PR
DTUNER_CVBS
AUDIO_MUTE_L
DTUNER_RESET
DTUNER_SD_H
DTUNER_RX
DTUNER_TX
DTUNER_POWER
DTUNER_PB
TU_I2C_CLK
DTUNER_PR
TU_I2C_DATA
DTUNER_CVBS
4
AUDIO_MUTE_L
DTUNER_SD_H
AFT_1
AFT_2
FROM/TO STEREO
DTUNER_RESET
DTUNER_POWER
DTUNER_RX
C5838
56P CH
C5839
56P CH
CD801
CH011208
ACCESSORY
I2SSD0_OUTA
I2SWS_OUTA
I2SSCLK_OUTA
I2SSD0_IN
I2SWS_IN
I2SSCLK_IN
SIF
TR3820
DTUNER_TX
ZCAT2035-0930A-BK
CD802
CH011208
DTUNER_SPDIF
3
NC
7
I2SSDO_OUTA
8
I2SWS_OUTA
9
I2SSCLK_OUTA
10
I2SSDO_IN
11
I2SWS_IN
12
I2SSCLK_IN
13
TU I2C DATA
14
TU I2C CLK
15
RF_SW
16
IF AGC
17
GND
18
GND
19
IF OUT1
20
IF OUT2
CD3820
4L0J-050-00K
I2SSD0_OUTA
I2SWS_OUTA
I2SSCLK_OUTA
I2SWS_IN
FILTER
V801
PDP42X3####
V802
FG410NAA-05
I2SSCLK_IN
BT001
MNAAA(R03)
BT002
MNAAA(R03)
TU_I2C_DATA
TM101
ORT204UA605025-J
TU_I2C_CLK
CD3831
CU012202
RF_SW
IF_AGC
2
IF_OUT_1
IF_OUT_2
1
NOTE: THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME
OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE
A
PANEL
I2SSD0_IN
NOTE:THE DC VOLTAGE AT EACH PART WAS MEASURED
WITH THE DIGITAL TESTER WHEN THE COLOR BROADCAST
WAS RECEIVED IN GOOD CONDITION AND PICTURE IS NORMAL.
H-17
C58120.01 B
0
SW
Q5802
RT1N241C
82K
C5813
SW
IC5801
3.4
CP5802 (CP2404)
TKC-W20P-U1
DTV_RESET
1
2
RF_SW
L5804
GND
0
P.CON+5V
33P CH 22uH
GND
8
UNREG+4V
C5811
7
8
C5809
REG +5V
7
0.47 B
UNREG+4V
6
6
5.0
UNREG+4V
5
5
0
4
11
0.3
UNREG+4V
UNREG+5V
R5806
IF AMP Q5803
2SC3841-T1B_T63
1
16V 10 V-S
2
1.9
3
W885
YK
L5803
1.9
3
C5810 0.1 B
1.9
4
W851
0
5.0
TC7W66FU
B
FROM/TO AV OUT
UNREG+5V
IF_AGC
6
5.0
C5808
2
IF_OUT_2
IF_OUT_1
C58070.01 B
W915
22uH
0305
0
0.1
5
17 IF OUT
23
W908
B
W914
SW
Q5801
RT1P431C
5.0
6.3V 220
L5802
C5802
0.1 B
C5806
C5820
P.CON+5V
CP5801 (CP2403)
TKC-W20P-U1
1
UNREG+5V
16 IF SW
15 SIF
14 +5V
13 V_OUT
12 AGC_OUT
11 AFT
10 SCL
9 SDA
8 AGC
56P CH
B
C5805
0.1
AFT
DTUNER_SPDIF
AFT_1
AFT_2
SIF
56P CH
0.1
P.CON+32V
C5819
C5817
B5805
BLM18PG181SN1D
0.1 B
BLM18PG181SN1D
C5803
C5816
B5802
B5803
BLM18PG181SN1D
C5815
0.1 B
0.1 B
6
7 +5V
6 GND
5 TU
4 +30V
3 GND
2 +5V
C5801
P.CON+5V
P.CON+32V
UNREG+5V
UNREG+4V
7
FROM/TO TUNER/OUT JACK
NC
B5801
BLM18PG181SN1D
NC
GND
6.3V 220 YK
7
FROM/TO SHIELD DIGITAL
21
DIGITAL/ANALOG TUNER W/NTSC_MPX
TU5801
ENG36A53KF
FROM/TO POWER
1 OOB
22
<== LCD TUMUDTR-V110V
B
THESE PARTS MARKED BY
CAUTION:SINCE
CRITICAL FOR SAFETY,USE ONES
ARE
DESCRIBED IN PARTS LIST ONLY
CAUTION: DIGITAL TRANSISTOR
CAUTION: DIGITAL TRANSISTOR
1
PIECES REPAREES PAR UN
ETANT
ATTENTION:LES
DANGEREUSES AN POINT DE VUE SECURITE
PCBD20
CMF083
N’UTILISER QUE CELLS DECRITES
DANS LA NOMENCLATURE DES PIECES
C
D
E
F
G
H
H-18
B
C
F
(SCALER PCB)
SCART_AUDIO_SW
DVB_RESET-L
DVB_POWER_CTL-H
DVB_MUTE-L
JG102
0
JG105
G
JG106
R134
R119
1K
0
D
G
5.6K
R193
STANDBY_LED
4.7K
JG127
3.2
R120
0
HDMI/DVI
1K
3.2
0
0
R121
SCALER_SW
R123
1K
1K
R122
YUV_SW
R126
HDMI_H
DV1000_RESET
0
JG131
0
R198
1K
0
R146100
0
3.2
R148
3.2
100
4SI_SDA_IN
4SI_SDA_OUT
6
4SI_SCL
4
4SI_SDA_IN
3
4SI_SDA_OUT
2
DVD_RX
100
CP101
A2001WV2-5P
1
DVD_TX
EEPROM_SCL
IIC_OFF
GND
4.7K
EEPROM_SCL
2
EEPROM_SDA
3
IIC_OFF
4
GND
5
4
ROM WRITER
MICON_DATA
CP102 A2001WV2-10P
1
GND
RESET IC
IC102 PST3229NR
R209
4.7K
EEPROM_SDA
4.7K
5
5
GND
1
A2001WV2-7P
PC_CONTROL CP103
0
NC
R128
7
RESET
CHIP_SELECT
4SI_SCL
3.2
R135
NC
0
NC
0
5
4
NC
NC
DVD_TX
DVD_RX
NC
RST1
OUT
IN
GND
1
2
3
3.4
3.4
0
CLK1
CNVSS
W820
AT+5V
10K
0
R149
GND
4
JG134
0
3
5.0
5.0
7
GND
6
5.0
8
VCC
5.0
5
A0
5.0
2
JG112
TX
2
BUSY
3
NC
4
VCC
5
CLK
6
RX
7
CNVSS
8
RESET
9
GND
10
2
1
IC103 AT24C256N-10SU-2.7
EEP ROM IC 256K
50V2.2 V-S
C131
50V 0.47 V-S
C128
0.01 B
100
R115
C125
100
R114
SDA1
0.1 F
D105
RB520S-30-TE61
SCL1
R163
DDVS
AT+3.3V
4SI_CHIP_SE
CLK1
R147
3.2
4.7K
R208
W897
SCALER_RESET
JG136 RST1
0
4.7K
4.7K
R110
D109
DVB_TX
100
4.7K
R116
NC
JG135
DVB_RX
R145
R140
34
31
1K
JG130
R138
25
COMPONENT/HDMI
AT+3.3V
R181
0
4.7K
24
4.7K
1K
JG129
TEST
0
6
SD_SW1
A1
0
4.7K
23
0 3.2 NC 0
STEREO_RESET
10K
SCL
0
4.7K
R117
100
27K
R109
0.1 B
REMOCON_IN
C118
R151
4.7K
R129
22
0
7
SDA
50
49
48
R178
0
R118
21
28
20
0 3.2
NC
KEY-B
SW
Q101
KRC103SRTK
NC
0
R127
18P CH
C114
X101
16MHz
100WT01611
14
18P CH
C111
0.1 B
C109
CNVSS
4SI_SDA_IN
4SI_SCL
0
KEY-A
4.9
NC
6.3V 100
V-S
C126
JG118
JG116
4.7K
R105
4.7K
R157
R156
4SI_SDA_OUT
3.3
COMPONENT/HDMI
0
4.7K
R106
4.7K
4.7K
4.7K
4.7K
R155
R154
4.7K
19
0
27
18
26
17
DDVS
16
LIGHT_CTL
15
SDA2
14
SCL2
13
C_SYNC_POP
12
0 3.09 3.2 3.2 3.3 3.16 3.2
DVD_TX
DVD POWER ON-H
11
SYNC_HD_IN
10
0 3.2 3.3
POWER ON-H
9
8
0
R164
7
0
(RST1)
DDHS
6
0
POWER_ON-H
5
POWER FAIL
4
REMOCON IN
3
RB520S-30-TE61
2
POWER_FAIL
1
4SI_CHIP_SE
44
45
100 NC
DVD_RX
R161
43
42
41
40
(CLK1)
26 NC
C_SYNC
39
38
27 SCL1
6.3V 220 V-S
37
35
99 DVD/AV3
28 SDA1
33
98 DIGI/ANA_CVBS
32
AVSS
DVB_TX
AVCC
0
SW
Q105
KRA103SRTK
5.0
0
DV1000_RESET
KEY-A
PANEL_READY
46
47
AFT_1(LOW)
EEPROM_SDA
DVB_FAN_ON-H
EEPROM_SCL
EXT_MUTE-H
AUDIO_MUTE
VCC2
HP_MUTE
VSS
SCART1_SW/S_DET!
SCART_AUDIO_SW
SCART3_SW
SCART2_SW/S_DET2
DVB_RESET-L
A_TUNER_AGC_IN
V_SYNC
HDMI_H
DVB_RX
VREF
DVD_SW-H
AUDIO_MUTE
YUV_SW
P.CON+3.3V
R160
P50/^WRL/^WR
SW_POP1
30
A_TUNER_AFT
KEY-B
0
SCALER_SW
HDMI_SW
10K
SD_SW1
36
PDP_RLY/PDPGO
FROM/TO HDMI MICON2
C110
SW_POP2
POD_DET
HDMI_H
AT+3.3V
P.CON+3.3V
SCALER-H
P.CON+5V
AT+5V
HDMI_H
DVB_SW-H
DVB_MUTE-L
DVB_POWER_CTL-H
50 SC2_CVBS_OUT-H
48 STANDBY_LED
FROM/TO INTERFACE_HDMI IC
FROM/TO REGULATOR
53
EPM
3.2 3.4 3.2 3.2 3.2
3
54
STEREO_RESET
51
55
COMPONENT/HDMI
VS_ON/CPUGO
D
S
4.7K
52
56
29
LCDON/PDWN
HDMI/DVI
AT+5V
5.6K
1K
AFT_2(HIGH)
R192
JG107 4.7K
57
COMPOSITE/RGB
DVB_ASPECT_IN
5VD
SD_H
77
79
80
81
82
83
85
86
84
58
4.7K
SCL1
SDA1
DDHS
DDVS
59
NC
FROM/TO ADC1
61
R107
0
NC
62
VCC1
0
1K
1K
65
XIN
R200
66
C113
0.1 B
0
67
XOUT
R103
C101
3.2
R199
DIGI/ANA_CVBS
DVD/AV3
0
3.2
68
VSS
0
JG137
69
RESET
KEY-A
0
CNVSS
3.2
0
(32KHz_IN)
3.2
0 3.4 3.2 3.2 3.2
DTV/DVD_SW
BYTE
0.1 B
0
MICON
IC101
OEC7147A
4SI_CLK
C104
3DY/C_RESET
4SI_DATA_IN
1.4
W907
AFT
DVB_AFT
KEY-B
LCD_H
4SI_DATA_OUT
0
PDP_RLY
78
76
VS_ON
0
60
5.0
3.3
R195
HDMI/DVI
87
3.2
NC
0
0 3.2
IIC_OFF
88
JG104
0
0
47
89
AFT_2[HIGH]
JG103
3.2
NC
0
HDMI_SW
4SI_CHIP_SE
4
4.7K
0 2.75 2.75
63
3.3
DVB_FAN_ON-H
0
64
FROM/TO JACK
EEPROM_SDA
EXT_MUTE-H
AFT_1[LOW]
49 SC2_AUDIO_OUT-H
90
R102
DVS
AFT_1[LOW]
SCALER_SW
AFT_2[HIGH]
DVB_MUTE-L
DVB_RX
DVB_TX
DVB_RESET-L
DVB_POWER_CTL-H
SD_H
3.2
100
0
76 SCALER-H
SW_SCART/COMPONENT_SW
91
PSU_5VD/DSR
0
4.7K
0 NC 0
75 HEADPHONE_IN
S_JACK_IN_DET
92
SW_SCART
SCART_AUDIO_SW
VS_ON
PDP_RLY
R175
1K
IIC_OFF
2.2K
5
0
SCALER_RESET
100
R142
93
HDMI_SW
JG120
SW_HD/SCART_Y
4.7K
R136
94
0
DVD_RESET
95
3.2
DISC_IN_DET
96
JG101
0.1 B
4.7K
0 NC 0 2.51
72 71 70
0
73
97
C106
SCALER_RESET
R158
S_DET
2.2K
R104
STEREO_RESET
SDA1
SCL1
4SI_SCL
4SI_SDA_IN
4SI_SDA_OUT
4SI_CHIP_SE
AUDIO_MUTE
SCALER_RESET
S_DET
3.2
0
NC
3.2
NC
0
SW_SCART
HP_MUTE
0.1 B
98
POWER_FAIL
POWER_ON-H
C123
SCALER-H
0
74
LEVEL SHIFT
Q106
KTK5132E
R141
100
0.1 F
0
75
100 99
6
SCART1_Y
DVS
C_SYNC
SCART2_SW
SCART1_SW
SCART1_Y
EXT_MUTE-H
C117
0.1 F
DVB_FAN_ON-H
DVD/AV3
DIGI/ANA_CVBS
STANDBY_LED
REMOCON_IN
AFT
6.3V 220
V-S
100
6.3V 220 V-S
C107
FROM/TO SCALER
100
R133
C116
R204
SD_H
R137
R205
R176
4.7K
4.7K
4.7K
JG114
R131
7
8
100
POWER_ON-H
HP_MUTE
SCART1_SW R132
SCART2_SW
EEPROM_SCL
5.0
3.3
R194
R177
SCL2
3.3
(32KHz_OUT)
SDA2
H
P.CON+5V
PSU_5VD/DSR
FROM/TO LVDS
G
LEVEL SHIFT
Q104
KTK5132E
S
8
E
3
10K
MICON SCHEMATIC DIAGRAM
D
C136
A
5.0
2
R188
EEPROM_SDA
W895
SDA2
TEST
VCC
VSS
8
A2
SCL2
7
SCL
W896
6
A1
R173
5.0
SDA
YUV_SW
0
5.0
5
100
SD_SW1
5.0
A0
R174
C_SYNC
4
3
2
1
100
CAUTION: DIGITAL TRANSISTOR
FROM/TO ADC2
1
A
H-19
CAUTION: DIGITAL TRANSISTOR
0
DV1000_RESET
SCL1
SDA1
NOTE:THE DC VOLTAGE AT EACH PART WAS MEASURED
WITH THE DIGITAL TESTER WHEN THE COLOR BROADCAST
WAS RECEIVED IN GOOD CONDITION AND PICTURE IS NORMAL.
B
C
D
E
0
0
IC104 AT24C256N-10SU-2.7
EEP ROM IC 256K
EEPROM_SCL
FROM/TO AV_SWITCH1
R189
10K
10K
0
1
PCBDS0
CEF156
NOTE: THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME
OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE
F
G
H
H-20
A
B
C
D
E
F
SCALER SCHEMATIC DIAGRAM
8
G
H
(SCALER PCB)
8
AFT
SCART1_B
GND
11
SCART1_G
12
GND
13
SCART1_R
14
15
GND
AFT_2/DTV_CVBS
16
GND
SCART1_Y
18
SCART2_SW
22
23
LCDON
DVB_FAN_ON-H
25
LCD-H/PDP_RLY
S_DET
27
SCART1_SW
28
SW_YUV1/2
HP_IN
SCART1_Y
POWER_FAIL
POWER_ON-H
AFT_1[LOW]
DVB_FAN_ON-H
NC
DTUNER_H
DTV_MUTE_L
GNP/INV_DET
W877
C801
1B
8
9
11
W821
NC
DVB_RX
0.1 B
DVB_TX
W983 DVB_RESET-L
SW_VIDEO_C
C818
0.1 B
SW_AUDIO_R[PC]
D803
UDZS5.6B
SW_B/SW_CB W807
GND
SW_AUDIO_L[PC]
NC
STEREO_RESET
16
SCART3_SW
SDA1
SCL1
20
GND
SCALER_SW
SDA1
0.1 B
W985
SD_H
C827
GND
W930 W809
SWITCH_VIDEO_Y
GND
SWITCH_VIDEO_C
15
W931 W802
SWITCH_CVBS
28
SW_VIDEO_Y
C820
DVB_POWER_CTL-H
GND
26
0.1 B
SCL1
W984
23 DTUNER_SD_H
25
0.1 B
C819
SCART_AUDIO_SW
DTUNER_POWER
GND
24
C817
STEREO_RESET
W990
SCART_AUDIO_SW
19
29
D802
C826
W982
SW_AUDIO_R(PC)
15
27
W805
SW_R/SW_CR
C812
0.1 B
C816
0.1 B
GND
18
3
6.3V 220
V-S
DVD/AV3
W981
GND
14
22
W979
W980DIGI/ANA_CVBS
W978 DVB_MUTE-L
13 SW_AUDIO_L(PC)
21
NC
SW_CVBS
C883 0.1 B
C815
VS_ON
DTUNER_RESET_L
12
17
W823
DTUNER_TX
10
0.1 B
C814
0.1 B
PSU_5VD/DSR
DTUNER_RX
GND
7
C823
0.1 B
SW_SCART
3
6
C824
PDP_RLY
SCART1_SW
2
5
DPR4
DPR5
DPR6
DPR7
DDVS
DDHS
NC
W874
C822
0.1 B
SCART2_SW
FROM/TO AV SWITCH2
(CP4203)
CP803
00_6232_029_006_800+
1
DVD/AV3_SW
4
6.3V 220
V-S
AFT_2[HIGH]
6.3V 220 V-S
S_DET
26
4
C2801
W987
30 LIGHT CTL/PSU_5VD
5
SW2_R/CR
POWER_ON-H
AFT_1
24
29
C2802
GND
17
21
SW2_G/Y
20
19 SC2 CVBS_OUT-H
20
POWER_FAIL
6
SW2_B/CB
19
SW_CVBS
0.1 B
SW_VIDEO_Y
16
W929
17
W801
3.4
3.4
3.4
3.4
3.4
3.4
3.4
3.4
0
C836 0.1 B 1.6
C837 0.1 B 1.2
C838 0.1 B 0.7
0.9
3.4
0
3.4
0
C839 0.1 B 1.6
C840 0.1 B 1.1
C841 0.1 B 0.7
1.3
C830 0.1 B 3.4
0
UDZS5.6B
3.4
0
3.4
0
C842 0.1 B
1.6
C843 0.1 B
1.1
C844 0.1 B
0.7
0.5
C832 0.1 B 3.4
2.0
0
C834 0.1 B
3.4
0
C845 0.1 B 1.6
C846 0.1 B 1.1
C847 0.1 B 0.7
0.5
NC
3.4
1.3
0
C859 0.1 B
C876 0.1 B 1.3
3.4
0
D805
0
UDZS5.6B
3.4
0
3.7
3.7
R807
10K
3.3
3.3
NC
3.4
SW_VIDEO_C
DPG3
DPG2
DPG1
DPG0
DDCK
DPG7
DPG6
DPG5
DPG4
DPB3
DPB2
DPB1
DPB0
214 PXD23
163 DGND
215 DVDD18
164 DVDD18
216 DGND
165 QBR4
DVDD33
QBR3
QBR2
QBR1
QBR0
DGND
DVDD33
QGR7
QGR6
QGR5
QGR4
QGR3
QGR2
DVDD33
DGND
DVDD18
QGR1
QGR0
QCLKR
QRL7
QRL6
QRL5
QRL4
QRL3
DVDD33
DGND
DVDD18
QRL2
QRL1
QRL0
QBL7
QBL6
QBL5
QBL5
QBL4
QBL3
QBL2
DVDD33
DGND
DVDD18
QBL1
QBL0
QGL7
QGL6
QGL5
DGND
DVDD33
QGL4
QGL3
QGL2
QGL1
TEST1
LPF1
TEST0
DVD33
SCALER
IC801
R8J66607A72FP
55
DGND
106 QGL0
56
DVDD18
107 DVDD18
57
MPWEL
108 DGND
DDHS
DDVS
DDCK
0
0
NC
0
NC
0
NC
0
NC
0
3.3
0
NC
0
NC
0
NC
0
NC
0
NC
0
NC
3.3
0
1.8
0
C889
NC
0
NC
0.1 B
0
NC
3.3
3.3
3.3
3.3
3.3
3.3
0
1.8
3.3
3.3
3.3
3.3
3.3
3.3
3.3
3.3
3.3
3.3
0
1.8
3.3
3.3
3.3
3.3
3.3
0
3.3
3.3
3.3
3.3
3.3
0
1.5 R835 10K
R834
0
3.3
SCALER_RESET
C856
1
C893
0.1 B
NR802
4D03WGJ0470T5E
DR9
DR8
DR7
DR6
C894
0.1 B
NR803
4D03WGJ0470T5E
C813 0.1 B
DR5
DR4
DR3
DR2
NR804
4D03WGJ0470T5E
DB9
DB8
DB7
DB6
DB5
DB4
DB3
DB2
C895
0.1 B
NR805
4D03WGJ0470T5E
NR806
4D03WGJ0470T5E
DG9
DG8
DG7
DG6
C896 0.1 B
NR807
4D03WGJ0470T5E
DG5
DG4
DG3
DG2
C821 0.1 B
DPB7
DPB6
DPB5
DPB4
DPB3
DPB2
DPB1
DPB0
POWER_FAIL
POWER_ON-H
HP_MUTE
STEREO_RESET
AUDIO_MUTE
SDA1
SCL1
4SI_CHIP_SE
4SI_SDA_OUT
4SI_SDA_IN
4SI_SCL
S_DET
SW_SCART
PDP_RLY
VS_ON
PSU_5VD/DSR
A
B
C
D
5
SCART_AUDIO_SW
DVS
FROM/TO ADC2
DR2
DR3
DR4
DR5
DR6
DR7
DR8
DR9
DG2
DG3
DG4
DG5
DG6
DG7
DG8
DG9
DB2
DB3
DB4
DB5
DB6
DB7
DB8
DB9
AFT_1[LOW]
DVB_FAN_ON-H
SCALER_SW
AFT_2[HIGH]
DVB_MUTE-L
DVB_RX
DVB_TX
DVB_RESET-L
DVB_POWER_CTL-H
4
SD_H
DVD/AV3
DIGI/ANA_CVBS
DCLK2
DVS
DHS
DEN
3
FROM/TO REGULATOR
P.CON+1.5V
P.CON+3.3V
GND
0.001
B
B
FROM/TO JACK
SW_AUDIO_R[PC]
SW_AUDIO_L[PC]
2
NOTE:THE DC VOLTAGE AT EACH PART WAS MEASURED
WITH THE DIGITAL TESTER WHEN THE COLOR BROADCAST
WAS RECEIVED IN GOOD CONDITION AND PICTURE IS NORMAL.
1
NOTE: THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME
OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE
H-21
6
SCALER_RESET
R836 C887
1K 0.01
C888
GND
DCLK1
470
DHS
DVS
DEN
6.3V 220
V-S
EXT_MUTE-H
21
C868
7PCH
C861
6.3V 220 V-S
4SI_SCL
4SI_SDA_OUT
4SI_SDA_IN
4SI_CHIP_SE
22
7
W905
54MHz
NR801
4D03WGJ0000T5E
7PCH
X801
W1014
R830
R825
1M
DCLK2
W1010
W883
C7238
2.2 B
C7239
2.2 B
C7240
2.2 B
C7241
2.2 B
C7242
2.2 B
W803
C898
0.1 B
FROM/TO AV SWITCH1
SW_G/SW_Y
SW_R/SW_CR
SW_B/SW_CB
SW2_R/CR
SW2_G/Y
SW2_B/CB
SW_CVBS
SW_VIDEO_Y
HD/SCART_Y
DPR7
DPR6
DPR5
DPR4
DPR3
DPR2
DPR1
DPR0
C892
0.1 B
47
R833
10K
R817
R818 10K
10K R819
R820 10K
10K R821
R82210K
10K R823
NC
R804 47
2
C891
0.1 B
C897
NC NC NC NC
0.1 B
C849
C850
0.1 B
6.3V 220
V-S
B
C835
0.1
C810
NC
DPG7
DPG6
DPG5
DPG4
DPG3
DPG2
DPG1
DPG0
10K
NC NC NC
NC NC NC
AFT
SCART1_Y
FROM/TO ADC1
60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100 101 102 103 104 105 106 107 108
NC NC NC NC NC
REMOCON_IN
SCART1_SW
216 215 214 213 212 211 210 209 208 207 206 205 204 203 202 201 200 199 198 197 196 195 194 193 192 191 190 189 188 187 186 185 184 183 182 181 180 179 178 177 176 175 174 173 172 171 170 169 168 167 166 165 164 163
DVDD33
PXD24
PDX25
PDX26
PDX27
VDIN
HDIN/FBIN
DVDD33
DGND
VRPD
VROD
VRMD
VIND
AVDDD2
AVSSD2
AVDDD1
AVSSD1
VRPC
VROC
VRMC
VINC
AVDDC2
AVSSC2
AVDCC1
AVSSC1
DVDD
DVSS
VRPB
VROB
VRMB
VIN1B
AVDDB2
VIN2B
AVSSB2
AVDDB1
AVSSB1
VRPA
VROA
VRMA
VIN1A
AVDDA2
VIN2A
AVSSA2
VIN3A
AVDDA1
AVSSA1
SVSS
DVDD33
DGND
RESET
QOECTL
HDIN2
VDIN2
DVDD33
55 56 57 58 59
STANDBY_LED
SCART2_SW
BLM18PG181SN1D
9
10
1SS355
18
P.CON+1.5V B805
GND
EXT_MUTE-H
DCLK1
109 110 111 112 113 114 115 116 117 118 119 120 121 122 123 124 125 126 127 128 129 130 131 132 133 134 135 136 137 138 139 140 141 142 143 144 145 146 147 148 149 150 151 152 153 154 155 156 157 158 159 160 161 162
8
1SS355
FROM/TO LVDS
PXD22
PXD21
PXD20
PXD17
PXD16
PXD15
DVDDSD
PXD14
PXD13
PXD12
PXD11
PXD10
PXD07
PXD06
DVDD33
DGND
DVDD18
PXD05
PXD04
PXD03
PXD02
PXD01
PXD00
PXCLK
DVDDSD
DGND
QBLCD
QBLCC
QBLCB
QBLCA
TSTCLK
QRR7
QRR6
QRR5
QRR4
DVDD33
DGND
DVDD18
QRR3
QRR2
QRR1
DVDD33
DGND
DVDDSD
QRR0
QBR7
QBR6
QBR5
EXT_MUTE-H
AUDIO_MUTE
D808
MPWEL
MPOE
MPCE
MPAH/PCXLKI
DVDDSD
MDQ15/C656IN7
MDQ14/C656IN6
MDQ13/C656IN5
MDQ12/C656IN4
MDQ11/C656IN3
DVDD33
DGND
DVDD18
MDQ10/C656IN2
MDQ9/C656IN1
MDQ8/C656IN0
MDQ7/C656OUT7
MDQ6/C656OUT6
MDQ5/C656OUT5
MDQ4/C656OUT4
MDQ3/C656OUT3
MDQ2/C656OUT2
MDQ1/C656OUT1
DVDDSD
DGND
MPSEL0
XIN
XOUT
MPSEL1
MDQ0_C656OUT0
QE/PXCLK0
QH
QV
QDRVHA/QDE
DVDD33
DGND
DVDD18
QDRVHB
QDRVHC
QDRVHD
QDRVHE
DVDD33
DGND
DVDDSD
QDRVHF
QDRVVA
QDRVVB
QCLKL
7
D807
C851
AUDIO_MUTE
0
0.1 B
3.3
3.3
3.3
3.3
3.3
3.3
3.3
3.3
3.3
C853
3.3
0.1 B
3.3
3.3
3.3
3.3
C857
3.3
0.1 B
3.3
3.3
C860
0
0.1 B
3.3
3.3
3.3
3.3
3.3
3.3
W810
3.3
3.3 B803 BLM18BB600SN1
3.3
0
C863
0
NC
0.1 B
0
NC
0
NC
0
NC
R831
0
0 NC
10K
0 NC
0 NC
C871
0 NC
0.1 B
3.3
0
1.8
0 NC
C873
0 NC
0.1 B
0 NC
C877
3.3
0.1 B
0
3.3
0 NC
C878
0 NC
0.1 B
0 NC
0 NC
0 NC
1.8
0
C886
0.1 B
HP_MUTE
6
FROM/TO MICON
HP_MUTE
B802 ANALOG+3.3V
5
W880
B801 DIGITAL+3.3V
NC
BLM18PG181SN1D
4
7
REMOCON_IN
54 53 52 51 50 49 48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33 32 31 30 29 28 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
AFT
0
1.8
3.3
3.3
3.3
3.3
B806
3.3
3.3
BLM18BB600SN1
3.3
C852 0.1 B 3.3
3.3
3.3
3.3
3.3
0
C855 0.1 B
1.8
3.3
C858 0.1 B 3.3
3.3
3.3
3.3
3.3
3.3
3.3
3.3
3.3
3.3
0
C862 0.1 B
R826 10K 0
1.8
1.8
R828
10K 0
R829
10K 0
3.3
R844
47 3.3
R845
47 3.3
3.3
3.3
0
C870 0.1 B
1.8
C872
0
0
0.1 B
0
C875
0
3.3
0.1 B
0
C879 0.1 B
3.3
0
0
0
B804 3.3
BLM18BB600SN13.3
1.8
0
C884 0.1 B
3
STANDBY_LED
BLM18PG181SN1D
REMOCON IN
GND
2
DPR3
DPR2
DPR1
DPR0
DPB7
DPB6
DPB5
DPB4
CP802 (CP4204)
00_6232_030_006_800+
1 STANDBY LED
P.CON+3.3V
FROM/TO TUNER/OUT JACK
E
F
PCBDS0
CEF156
G
H
H-22
A
B
C
D
E
F
G
H
ADC1 SCHEMATIC DIAGRAM
8
8
(SCALER PCB)
FROM/TO MICON
SCL1
SDA1
DDHS
0.1 B
C2125
VD
36
37
0 0.4
GND
VD
CLAMP
MIDSCV
38
39
0 3.3
C2131
0.1 B
0.1 B
C2145
0.9
C2143
0.5
0
3.3
3.3
C2132
0.1 B
C2138
0.1
0
0
B
0.047 B
C2129
0.1
B
40
0
R2109
4
L2107
C2139
0.5
3.3
0.001 B
0.047 B
0.1 B
R2108
5
C2137
BUFFER
Q2101
KTA1504S_Y_RTK
22uH
NLCV32T
C2151
0
220 V-S
120
100P CH
3.3
C2133
6.3V
R2111
0.047 B
C2150
3.3
C2144
R2110
60
59
57
56
55
54
53
52
51
50
49
48
0
1K
PVD
GND
PVD
FILT
GND
32
33
34
35
0 1.3 1.3 3.3
C2124
28
29
30
31
0 3.3
3.8 3.8
C2120 R2103
25
26
27
0 3.3 3.3
VSYNC
24
0
COAST
21
22
23
0 3.3 3.3
GND
HSYNC
BLUE0
0.5
0.1 B
GND
BAIN
0
C2149
GND
3.9
6.3V 220 V-S
41
0.1 B
FROM/TO AV SWITCH1
27
1K
GND
C2136
3.9
120
21
41
BLUE1
0.1 B
100
VD
1.3
6
C2130
R2112
BLUE3
3.3
15uH
NLV32T
VD
0
L2106
BLUE4
47
GND
46
BLUE5
45
GAIN
44
BLUE6
43
SOGIN
42
BLUE7
GND
BLUE2
58
VD
GND
VSOUT
HSOUT
SOGOUT
DATACK
GND
VDD
RED7
RED6
RED5
RED4
RED3
RED2
RED1
100
R2107
100
R2104
DDVS
B2101
DDCK
BLM18BB600SN1
DDHS
DPR4
DPR5
DPR6
DPR7
NR2105
4D03WGJ0101T5E
RED0
VDD
VDD
1
2
3
4
5
6
7
8
VDD
0.039 B 8.2K
ANALOG
L2101
VD
0.0039 B
3
C2106
47uH
NLCV32T
MST9883C-LF-110
C2116
L2103
DIGITAL
GND
1K
0
VD
R2102
3.3
GREEN0
GND
DPB7
DPB6
DPB5
DPB4
DPB3
DPB2
DPB1
DPB0
3.3
GND
AD CONVERTER
IC2101
PVD
NR2104
4D03WGJ0101T5E
DPB3
DPB2
DPB1
DPB0
GREEN1
PVD
3.3
RAIN
GND
3.3
GREEN2
GND
3.3
A0
VDD
3.3
GREEN3
0.1 B
3.3
SCL
VDD
3.3
NR2103
4D03WGJ0101T5E
DPB7
DPB6
DPB5
DPB4
DPR7
DPR6
DPR5
DPR4
DPR3
DPR2
DPR1
DPR0
4
3.3
B
GREEN4
C2111
0.1
SDA
0.1 B
C2105
DPG7
DPG6
DPG5
DPG4
DPG3
DPG2
DPG1
DPG0
GREEN5
C2109
0
GND
9
DDHS
DDVS
DDCK
61
10
3.3
GND
11
FROM/TO INTERFACE_HDMI IC
80
12
5
3.3
REF BYPASS
13
NR2102
4D03WGJ0101T5E
DPG3
DPG2
DPG1
DPG0
VD
GREEN6
14
3.3
GND
15
3.3
0
61
16
3.3
0 3.3
63
62
GREEN7
17
DPB7
DPB6
DPB5
DPB4
DPB3
DPB2
DPB1
DPB0
3.3
GND
18
3.3
NR2101
4D03WGJ0101T5E
DPG7
DPG6
DPG5
DPG4
19
3.3
20
0
DPR7
DPR6
DPR5
DPR4
DPR3
DPR2
DPR1
DPR0
7
0 NC 3.1
65
64
0 3.0 3.1
68
67
66
0 3.3 3.3 3.3 3.3 3.3 3.3 3.3 3.3 3.3 3.3 3.3
80
79
78
77
76
75
74
73
72
71
70
69
6.3V 100 V-S
6
W967
DPG7
DPG6
DPG5
DPG4
DPG3
DPG2
DPG1
DPG0
0.1 B
C2110
DDHS
DDVS
DDCK
0.1 B
C2108
FROM/TO SCALER
1
23
NR2106
4D03WGJ0101T5E
DPR0
DPR1
DPR2
DPR3
DDVS
7
SW_PR/R
5.0
R2114
28
SW_Y/G
0.7
100
0
29
SW_PB/B
3
22uH
NLCV32T
C2127
6.3V 220 V-S
0.1 B
6.3V 220 V-S
C2121
0.1 B
C2113
0.1 B
22uH
NLCV32T
C2112
C2103
GND
6.3V 100 V-S
L2102
P.CON+3.3V
C2126
FROM/TO REGULATOR
FROM/TO JACK
R2106
R2115
2
VGAVS
33
VGAHS
2
33
P.CON+5V
NOTE:THE DC VOLTAGE EACH PART WAS
MEASURED WITH THE DIGITAL TESTER
DURING PLAYBACK.
NOTE: THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME
OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE
PCBDS0
CEF156
1
1
A
H-23
B
C
D
E
F
G
H
H-24
A
B
C
D
E
F
ADC2 SCHEMATIC DIAGRAM
H
(SCALER PCB)
DBO9
DV1000_RESET
DVS
47
R7506
FROM/TO LVDS
47
R7508
DEN
DHS
DGO5
DGO4
DGO3
DGO2
8
NR7504
4D03WGJ0470T5E
NR7503
4D03WGJ0470T5E
DGO9
DGO8
DGO7
DGO6
8
G
FROM/TO MICON
DBO4
DV1000_RESET
SDA1
C7511
0.1 B
47
R7512
JG7507
DBO5
JG7506
DBO6
C7506
7
0.1 BC7507
DBO7
0.1 B
DBO8
7
SCL1
DBO3
DBO2
DB9
DGO9
DBO6
DBO7
DBO8
DBO9
3.3
3.3
3.3
NR7502
4D03WGJ0470T5E
0
R_CR_OUT6
B_CB_CRCB_OUT4
VSS
34 R_CR_OUT1
B_CB_CRCB_OUT5
33 R_CR_OUT0
VSS
R_CR_OUT4
127 B_CB_CRCB_OUT9
32 G_Y_IN9
VCC_BUF
R_CR_OUT3
2 R_CR_IN1
B_CB_CRCB_OUT6
1 R_CR_IN0
B_CB_CRCB_OUT7
B_CB_CRCB_OUT8
1
0
R_CR_OUT5
128 VSS
2
3
4
5
0 3.1 3.1 3.1
31 G_Y_IN8
R_CR_OUT2
VCC_CORE
VCC_BUF
61
60
59
58
57
55 56
54
53
52
FROM/TO SCALER
C7514
DCLK2
0.1 B
0
DHS
R7510
50
3.3
49
3.3
48
3.3
0
47
51
JG7513
JG7514
0
3.3
46
B_CB_CRCB_OUT3
W973
0
45
R_CR_OUT7
0
3.3
44
B_CB_CRCB_OUT2
W872
1.8
3.3
3.3
3.3
0
3.3
3.3
3.3
3.3
1.8
3.3
0
0
6
DB2
0
43
R_CR_OUT8
DB3
3.3
42
VCC_CORE
62
63
64
CLARITY_IN3
CLARITY_IN4
CLARITY_IN5
CLARITY_IN6
CLARITY_IN7
RESET_N_IN
VCC_CORE
VSS
VSYNC_IN
HSYNC_IN
FIELD_IN
TEST_IN
WINDOW_ENABLE_IN
SC_ADD_10BIT_7BIT_N_IN
G_Y_OUT0
G_Y_OUT1
VSS
VCC_BUF
VCC_CORE
G_Y_OUT2
G_Y_OUT3
G_Y_OUT4
VSS
G_Y_OUT5
G_Y_OUT6
R_CR_OUT9
VSS
DB4
3.3
41
3.3
VSS
3.3
40
0.1 B
3.3
B_CB_CRCB_OUT1
DB5
39
C7504
VCC_BUF
DB6
3.3
38
0
B_CB_CRCB_OUT0
DB7
37
3.3
NR7501
4D03WGJ0470T5E
CLK_SYSTEM
OUTPUT_ENABLE_N_IN
HBLANK_IN
DB8
3.3
36
3.3
VBLANK_IN
0.1 B
3.3
35
3.3
SCL
VIDEO_ENHANCER
IC7501
DV1000-75
C7513
3.3
34
3.3
CLK_VIDEO
3.3
33
1.8
SDA
G_Y_IN7
C7503
PROCESS_CONTROL_IN
G_Y_IN6
0
DBO2
DBO3
DBO4
DBO5
3
0
JG7503
VSS
VSS
JG7502
0.1 B
4
0
PROCESS_CONTROL_IN
G_Y_IN5
0
BLM18BB600SN1
B7501
W854
0
VCC_CORE
G_Y_IN4
3.3
VCC_CORE
G_Y_IN3
0
DENO
B_CB_CRCB_IN0
TEST_IN
G_Y_IN2
0
B_CB_CRCB_IN1
VCC_BUF
G_Y_IN1
0.1 B
DVS
B_CB_CRCB_IN2
63 B_CB_CRCB_IN8
TEST_OUT
G_Y_IN0
DHS
5
1.8
B_CB_CRCB_IN3
64 VCC_BUF
TEST_MODE3
VCC_CORE
0.1 BC7505
65 B_CB_CRCB_IN9
VCC_BUF
3.3
DRO2
95 G_Y_OUT8
HSYNC_OUT
0
JG7501
C7502
DRO3
B_CB_CRCB_IN4
66 CLARITY_IN0
VSYNC_OUT
DRO4
TEST_MODE2
B_CB_CRCB_IN5
67 CLARITY_IN1
WINDOW_ENABLE_OUT
0
DRO5
68 CLARITY_IN2
VSS
DRO6
3.3
B_CB_CRCB_IN7
B_CB_CRCB_IN6
96 G_Y_OUT9
FIELD_OUT
W869
TEST_MODE1
HBLANK_OUT
DRO7
97 SC_ADD_CTRL_IN
TEST_MODE0
VBLANK_OUT
0
VCC_BUF
3.3
DRO8
R_CR_IN9
W870
DRO9
98 SC_ADD_CTRL_IN
SC_ADD_CTRL_IN
R_CR_IN8
0
SC_ADD_CTRL_IN
R_CR_IN7
DGO2
SC_ADD_CTRL_IN
R_CR_IN6
0
R_CR_IN5
DGO3
6
VSS
3.3
R_CR_IN4
W871
DGO4
R_CR_IN3
DGO5
R_CR_IN2
0
98
0
DGO6
128 127 126 125 124 123 122 121 120 119 118 117 116 115 114 113 112 111 110 109 108 107 106 105 104 103 102 101 100 99
DGO7
97
DGO8
G_Y_OUT7
3.3 3.3 3.3 3.3
0 3.3 3.3 3.3 3.3 1.8 3.3
0
0
0
0
0 3.3 3.3 3.3 3.3
0 1.8 3.3
0
0
0
0
0
0
0
0 3.3
96 95 94 93 92 91 90 89 88 87 86 85 84 83 82 81 80 79 78 77 76 75 74 73 72 71 70 69 68 67 66 65
R7509
100
SDA1
100
SCL1
DB9
DB8
C7518
4
0.1 B
C7515
5
DVS
DEN
0.1 B
1
NC
3 OSC
X7501
2 20MHz
DB7
DB6
DB5
DB4
DB3
DRO9
DRO8
DRO7
DRO6
DB2
4
DG9
NR7505
4D03WGJ0470T5E
DG8
DG7
DG6
DG5
DRO5
DRO4
DRO3
DRO2
DG4
DG3
DG2
NR7506
4D03WGJ0470T5E
C7512
DR9
0.1 BC7516
DR8
0.1 B
JG7511
DR7
DR6
JG7512
3
DR5
DR4
7
8
9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32
6
0 3.1 3.1 3.1 3.1 3.1 3.3
0
0
0
0 3.4 3.3 3.3 3.3 1.8
0
0 3.3 3.3 3.3 3.3
0 3.3 3.3 3.3 3.3
DR3
C7521
6.3V 47 V-S
C7519
6.3V 47 V-S
W975
W974 0.1 B
0.1 C7510
B
33 R7507
C7509 33
R7505 33
BLM18PG181SN1D L7502
47uH
NLCV32T
FROM/TO REGULATOR
P.CON+1.8V
P.CON+3.3V
GND
DENO
2
1
B
C
D
DG9
DG8
DG7
DG6
NOTE: THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME
OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE
NOTE:THE DC VOLTAGE AT EACH PART WAS MEASURED
WITH THE DIGITAL TESTER WHEN THE COLOR BROADCAST
WAS RECEIVED IN GOOD CONDITION AND PICTURE IS NORMAL.
A
DG5
DG4
DG2
DR9
DR8
DR7
DR6
DR5
DR4
DR3
DR2
DCLK2
DHS1
DG3
JG7509
DVS1
JG7510
2
H-25
B7502
R7513
C7508
0.1 B
JG7505
W989
W988
JG7504
DR2
JG7515
JG7508
JG7500
E
F
1
PCBDS0
CEF156
G
H
H-26
A
B
C
D
E
F
G
H
LVDS SCHEMATIC DIAGRAM
(SCALER PCB)
DGO3
3.3
DGO7
3.3
DGO8
3.3
FROM/TO SCALER
DCLK1
TxIN13
TxOUT1+
0
GND
LVDSVcc
TxIN14
LVDSGND
DBO4
3.3
TxIN15
TxOUT2-
56
55
DRO8
3.3
DRO7
3.3
DRO6
7
0
3.3
DRO5
3.3
DRO4
3.3
DRO2
0
1.3
6
NR7204
4D03WGJ0220T5E
PDP_TXOUT0PDP_TXOUT0+
PDP_TXOUT1PDP_TXOUT1+
1.2
1.3
1.2
C7227
3.2
0.1 B
0
DBO7
3.3
DBO8
3.3
DBO9
DHS1
DVS1
DENO
3.3
LVDSGND
GND
42
41
40
39
38
37
TxOUT3+
TxIN19
TxIN20
PLLGND
TxIN21
PLLVcc
TxIN22
PLLGND
SDA2
SCL2
POWER_ON-H
3.3
DVS1
3.3
32
TxCLKIN
Vcc
TxIN24
TxIN26
TxIN25
GND
31
25
26
PWRDWN
30
DHS1
TxIN23
29
FROM/TO MICON
R7206
1.2
22
R7207
PDP_TXOUT3PDP_TXOUT3+
0
4
3.3
27
3.3
1.3
PDP_L
CP7202
FI-TWE31PB-VF
1
GND
0
0
NC
49
1.3
22
36
16
17
TxOUT3-
1.2
5
PDP_TXOUT2PDP_TXOUT2+
PDP_TXCLKOUTPDP_TXCLKOUT+
35
DRO9
DRO8
DRO7
DRO6
DRO5
DRO4
DRO3
DRO2
NR7203
4D03WGJ0220T5E
C7226
PDP_TXOUT0-
0.1 B
PDP_TXOUT0+
34
0
TxIN18
33
DBO6
3.3
18
3.3
TxCLKOUT+
19
DBO5
TxIN17
20
3.3
TxCLKOUT-
21
DBO3
R-FB
22
0
1.2
1.3
TxOUT2+
TxIN16
23
3.3
24
DBO2
DGO9
DGO8
DGO7
DGO6
DGO5
DGO4
DGO3
DGO2
3
3.3
FROM/TO ADC2
DBO9
DBO8
DBO7
DBO6
DBO5
DBO4
DBO3
DBO2
4
3.3
28
5
DGO9
54
TxOUT1-
53
TxIN12
52
TxOUT0+
51
TxIN11
50
TxOUT0-
49
Vcc
0.1 B
48
LVDSGND
47
TxIN10
46
TxIN27
45
2
TxIN9
44
3.3
TxIN0
GND
43
C7218
3
3.3
4
DGO2
5
3.3
6
DGO6
TxIN8
7
3.3
TxIN1
8
6
DGO5
GND
9
0
TxIN7
10
3.3
TxIN2
TxIN6
11
DGO4
TxIN3
TxIN5
12
DRO9
3.3
7
TxIN4
RS
13
DRO3
3.3
1
LVDS IC7202
PDP_L/LCD_ALL ICSV385AGLFT
3.3
14
W830
8
15
0.1 B
C7221
8
0
PDP_TXOUT1PDP_TXOUT1+
3.3
PDP_TXOUT22.8
W882
B7202
DCLK1
BLM18BB600SN1
PDP_TXOUT2+
PDP_TXCLKOUT-
3.3
DENO
C7229
6.3V 220 V-S
R7211
1
C7219
4V 330 V-S
GND
SCL2
C7209
47uH
NLCV32T
47uH
NLCV32T
6.3V 220
V-S
L7203
L7202
POWER_ON-H
SDA2 W834
C7208
47uH
NLCV32T
B
C
D
6
RXIN2-
7
RXIN2+
8
RXIN3-
11
RXIN3+
12
GND
13
GND
14
NC
NC
15
NC
NC
16
NC
NC
17
NC
NC
18
GND
19
NC
NC
20
NC
NC
21
NC
NC
22
NC
NC
23
RXIN4-
24
RXIN4+
25
GND
26
DISPEN
27
I2C SDA
28
I2C SCL
29
4.7K
4.7K
W889
W835
NC
NC
30
GND
31
3
CD7206
CUZV6301
2
1
NOTE:THE DC VOLTAGE AT EACH PART WAS MEASURED
WITH THE DIGITAL TESTER WHEN THE COLOR BROADCAST
WAS RECEIVED IN GOOD CONDITION AND PICTURE IS NORMAL.
A
H-27
R7210
P.CON+3.3V
5
GND
9
0.1 B
C7222
180
6.3V 220
V-S
C7202
L7201
P.CON+3.3V
C7203 0.1 B
FROM/TO REGULATOR
0.1 B
C7201
2
4
RXIN1+
10
PDP_TXOUT3+
R7201
3
RXIN1-
RXCLK IN+
PDP_TXCLKOUT+
0.1 B
2
RXIN0+
RXCLK IN-
PDP_TXOUT30
RXIN0-
NOTE: THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME
OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE
E
F
PCBDS0
CEF156
G
H
H-28
A
B
C
D
E
F
G
H
JACK SCHEMATIC DIAGRAM
8
8
(SCALER PCB)
FROM/TO INTERFACE_HDMI IC
DVI_A_IN_L
DVI_A_IN_R
HDMI_A_IN_L
HDMI_A_IN_R
FROM/TO SCALER
YUV/HDMI/DVI Rch SW
IC4305
7
SW_AUDIO_R[PC]
SW_AUDIO_L[PC]
NJM2534V
0
4.7
BUFFER
6
5
4
5.2
4.8
3
NC
5
DGND
6
AGND
7
AGND
8
AGND
9
NC
10
DGND
10K
0
7
4.5
5.2
4.8
C4324
16V100 V-S
R4328
5
2.4
4.7K
R4333
R4324
R4316
VGAVS
VGAHS
C4378
R4329
R4320
0.001 B
R4315
NC
CH 470P
C4372
PC_A_IN_L
PC_A_IN_R
CH 470P
26
KEY-B
KEY-A
D4301
VGA-R
FROM/TO OPERATION/SIDE JACK/
REMOCON/FILTER/POWER SWITCH
CP2200(CP2203)
A2001WV2-3P
GND
1
KEY B
2
KEY A
3
UDZS5.6B
D4302
VGA-G
UDZS5.6B
B4305
4
VGA-B
BLM18BB600SN1
10K
FROM/TO REGULATOR
P.CON+9V
NC
11
NC
NC
12
DDCD
NC
13
VGAHS
14
VGAVS
15
DDCC
75
R4310
VGA-B
4
1B
FROM/TO ADC1
25
R4309
10K
B4304 BLM18BB600SN1
R4305
3
BUFFER
Q4305
KTC3875S_Y_RTK
VGA-R
VGA-G
VGA-B
C4357
5.4
B4303 BLM18BB600SN1
75
R4308
4
VGA-G
3.0
1 B
B
D-SUB
CP4302
1-1734344-1
VGA-R
1
2
3.0
0.001
C4362
C4366
1K
C4314
4.7K
MMZ1608R102CT
8.5
180K
R4319
R4313
8.5
220K
B4308
BUFFER
Q4302
KTC3875S_Y_RTK
FROM/TO AV SWITCH1
6
9.1
BAIAS
GND
75
5
180K
3
E
RED
R
220K
H1
2
1 B
SW_AUDIO_L[PC]
5
C4315
NC
1
1K
6
8
1
2
3
1B
COMPONENT/HDMI
4
H2
C4351
DVI_A_IN_L
4
R4314
MMZ1608R102CT
FROM/TO MICON
COMPONENT/HDMI
HDMI/DVI
KEY-A
KEY-B
BUFFER
4.8
DVI_A_IN_R
B4307
4.7
1B
NLCV32T
22uH L4306 P.CON+9V
1B
C4350
HDMI/DVI
AUDIO IN(DVI1/PC)
J4301
MSD-242VA1-03_NI_FE_LF
WHITE L
C4358
YUV/HDMI/DVI Lch SW
IC4304
NJM2534V
HDMI_A_IN_R
HDMI_A_IN_L
4.6
C4337
16V 100V-S
6
0.1 B
47uH
NLCV32T
C4328
P.CON+9V
L4301
SW_AUDIO_R[PC]
4.5
4.8
BAIAS
9.1
1B
W892
PC_A_IN_L
4.6
3
C4353
7
2
1B
W891
PC_A_IN_R
R4304
VGAHS
R4323 10
10
VGAVS
NC
3
2
2
NOTE:THE DC VOLTAGE AT EACH PART WAS MEASURED
WITH THE DIGITAL TESTER WHEN THE COLOR BROADCAST
WAS RECEIVED IN GOOD CONDITION AND PICTURE IS NORMAL.
1
A
H-29
7
8
1
C4352
B
C
D
NOTE: THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME
OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE
E
F
PCBDS0
CEF156
G
1
H
H-30
A
B
C
D
E
F
G
H
8
8
AV SWITCH1 SCHEMATIC DIAGRAM
(SCALER PCB)
SW2_G/Y
SW2_G/Y_1
W1016
7
7
R8105
SW_G/SW_Y
270
SW2_B/CB
SW2_B/CB_1
W1017
SW_B/SW_CB
R8122
1K
R8146
1K
R8143
270
SW_Y/G
SW_PB/B
SW2_R/CR_1
SW_PR/R
R8148
R8124
SW_R/SW_CR
6
BUFFER
Q8106
KTA1504S_Y_RTK
0.7
100
NLCV32T
L8105
0
BUFFER
Q8105
KTA1504S_Y_RTK
0
C8150
0.7
100
C8149
5.0
R8145
6.3V 220 V-S
B 0.1
270
P.CON+5V
22uH
C8151
5.0
100P CH
W1018
SW2_R/CR
6
5
W963
SW2_B/CB_1
W964
SW2_G/Y_1
W972
SW2_R/CR_1
5
GND1
IN1B
IN1A
16V 10
V-S-NP
1M
1M
R8118 R8117
YUV_SW
L8104
4.8
C8124
2.5
0
2.5
C8126
9
10
11
12
8
NC
16V 10
V-S-NP
3.1
16V 47 V-S
IN2B
C8123
16V 10
V-S-NP
1M
OUT1
13
V+
14
GND2
2.4
1M
2.4
CTL
0
C8122
16V 10
V-S-NP
P.CON+5V
47uH
NLCV32T
4
VGA-R
C8125
VGA-B
16V 10
V-S-NP
SW IC8104 NJM2584AM(TE1)
VGA-G
P.CON+5V
NC
4.7K
C_SYNC
0.7
12K
C8147
R8128
B 1
820P CH
C8146
C8144
12K
SYSNC_SEPA
Q8102
KTC3875S_Y_RTK
3.1
0.3
0
2
P.CON+9V
SD_SW1
SW_CVBS
SW_VIDEO_Y
1.5 R8125
0.1 B
100K
5.5
SYSNC_SEPA
Q8103
1.0
KTC3875S_Y_RTK
R8130
0
2.7K
1K
1B
2
C8131
1 B
R8113
R8123
5.1
16V 100 V-S
3
0
R8116
820K
1B
L
C8128
3.3K
SYSNC_SEPA
Q8101 5.1
KTA1504S_Y_RTK
330P CH
R8119
P.CON+5V
6
C8110
4.4
BUFFER
C8113
P.CON+9V
8.9
C8137
0
GND
VCC
2
1B
FROM/TO REGURATER
H
5.1
1
1B
5
C8109
4
C8112
SW_PR/R
47uH
SW_PB/B
R8129
L8102
NLCV32T
SW_Y/G
C8129
SCART2 OUT CVBS SW
IC8103 MM1501XNRE
0.1 B
FROM/TO ADC1
3
1K
R8131
W971
3
0
NC
OUT2
2.0
R8121 R8120
C8120
FROM/TO SCALER
HD/SCART_Y
SW_VIDEO_Y
SW_R/SW_CR
SW_G/SW_Y
SW_B/SW_CB
SW2_R/CR
SW2_G/Y
SW2_B/CB
SW_CVBS
1M
R8114
4
2.0
IN2A
15
W900
OUT3
16
0
C_SYNC
SD_SW1
YUV_SW
7
FROM/TO MICON
GND3
6
1.8
NC
4
W944
1.0
IN3B
3
NC
1M
R8115
W843
0
IN3A
2
1.7
16V 10
V-S-NP
1
C8121
VGA-G
VGA-R
VGA-B
5
FROM/TO JACK
NOTE:THE DC VOLTAGE AT EACH PART WAS MEASURED
WITH THE DIGITAL TESTER WHEN THE COLOR BROADCAST
WAS RECEIVED IN GOOD CONDITION AND PICTURE IS NORMAL.
NOTE: THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME
OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE
PCBDS0
CEF156
1
1
A
H-31
B
C
D
E
F
G
H
H-32
A
B
C
D
E
F
G
H
REGULATOR SCHEMATIC DIAGRAM
8
8
(SCALER PCB)
5
P.CON+3.8V
6
P.CON+3.8V
7
GND
8
GND
9
GND
10
P.CON+5V
11
AT+5V
470P CH
470P CH
C3207
C3204
BLM18PG181SN1D
B3202
BLM18PG181SN1D
P.CON+5V
P.CON+3.3V
AT+3.3V
P.CON+5V
BLM18PG181SN1D
B3203
GND
BLM18PG181SN1D
GND
B3206
BLM18PG181SN1D
FROM/TO SCALER
P.CON+5V
P.CON+3.3V
P.CON+1.5V
GND
B3207
6
FROM/TO ADC1
W857
P.CON+5V
AT+3.3V
7
P.CON+9V
B3205
470P CH
4
B3201
C3203
3
NC
470P CH
C3205
P.CON+9V
C3201
2
470P CH
7
470P CH
C3206
FROM/TO POWER
CP3201 (CP3807)
A2001WV2-11P
1
P.CON+12V
6
AT+5V
BLM18PG181SN1D
3.3V_REG
IC3201
BA00BC0WFP
1.5V_REG
IC3202
BD7820FP
DS
FROM/TO MICON
DS
SCALER-H
AT+3.3V
1.6
AT+5V
5
P.CON+5V
0.7
HDMI_H
R3221
GND
1K
+-1%
D3207
D3206
EC31QS04 EC31QS04 EC31QS04
P.CON+1.5V
1K
+-1%
3.9K
+-1%
220
D3212
R3216
R3212
R3238
C3213
6.3V 100 V-S
1 F
1 F
C3211
0
P.CON+3.3V
5
C3212
2.8
4
10K
6.8K
+-1%
W859
2.7
R3220
SCALER-H
6
R3222
1.2
R3211
2
10 +-1%
3.3
1
R3237
0
5
C3217
4.1
4
GND V_OUT V_ADJ
6.3V 100 V-S
2.7
6
V_IN
1 F
2
V_C
1 F
C3215
1
GND V_OUT V_ADJ
C3216
V_IN
330
V_C
330
R3217
10K
R3209
P.CON+3.3V
FROM/TO LVDS
5
P.CON+3.3V
GND
FROM/TO JACK
P.CON+5V
P.CON+9V
GND
1.8V_REG
IC3203
BD7820FP
FROM/TO INTERFACE_HDMI IC
DS
HDMI+5V
4
4
HDMI_VNREG+5V
P.CON+9V
GND
V_C
V_IN
1
2.7
R3232
GND V_OUT V_ADJ
2
6
2.8
4
1.8
0
FROM/TO HDMI_MICON2
5
0.7
R3234
HDMI+5V
GND
10K
RXT_RST#
680
+-1%
R3235
P.CON+1.8V
FROM/TO AV SWITCH1
P.CON+9V
P.CON+5V
10
C3224
1 F
HDMI_VNREG+5V
R3236
W860
3
6.3V 100 V-S
EC31QS04
C3222
EC31QS04
1K
+-1%
D3209
1 F
C3223
D3208
3
GND
THESE PARTS MARKED BY
CAUTION:SINCE
CRITICAL FOR SAFETY,USE ONES
A
10K 0.6
0
R3244
10K
FROM/TO ADC2
P.CON+1.8V
P.CON+3.3V
W1013
8.2K
R3228
HDMI_H
0
SW
0
Q3210
KTC3875S_Y_RTK
SW
Q3211
KTC3875S_Y_RTK
2
GND
2.2
B
W1007
CAUTION: DIGITAL TRANSISTOR
PIECES REPAREES PAR UN
ETANT
ATTENTION:LES
DANGEREUSES AN POINT DE VUE SECURITE
ARE
DESCRIBED IN PARTS LIST ONLY
H-33
C3218
1.8
0
1
W1015
0
2.2
B
C3219
R3224
SW
Q3206
KRC102SRTK
R3245
1K
2
HDMI+5V
SW
Q3205
2SB1132
4.3
RXT_RST#
3.3
5.0
0
22K
R3223
5.0
10K
R3246
AT+3.3V
N’UTILISER QUE CELLS DECRITES
DANS LA NOMENCLATURE DES PIECES
B
C
1
NOTE:THE DC VOLTAGE AT EACH PART WAS MEASURED
WITH THE DIGITAL TESTER WHEN THE COLOR BROADCAST
WAS RECEIVED IN GOOD CONDITION AND PICTURE IS NORMAL.
D
E
NOTE: THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME
OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE
F
G
PCBDS0
CEF156
H
H-34
A
B
C
D
E
F
G
H
INTERFACE_HDMI IC SCHEMATIC DIAGRAM
8
(SCALER PCB)
D3605
FROM/TO ADC2
RB160L-40
RXT0_RST
220K
C3600
0.1 F
C3618
6.3V 22
V-S
0.1 F
C3654
C3610
0.001 B
0.1 F
C3625
0.001 B
C3620
82 +-1%
C3616 0.01 B
C3719
16V10 V-S
R3622
0.01 B
R3651
0.001 B
C3619
C3716
0.001 B
C3715
0.1 F
C3608
0.001 B
0.001 B
C3714
100 +-1%
C3632
0.001 B
JG3603
C3713
ANGY
JG3602
ANRPR
RXT1_RST
220K
10 B
R3680
ANBPB
JG3604
CSCL
CSDA
10K
C3617
10 B
R3713
W968
R3638
4.7K
4
10K
0.01 B
R3711
0.001 B
DVI_A_IN_R
C3612
2.8
3.3
3.3
+-1%
R3707
FROM/TO JACK
1.8V_REG
IC3601
BD7820FP
DVI_A_IN_R
DVI_A_IN_L
HDMI_A_IN_R
DS
HDMI_A_IN_L
220
3.3
6.8K
+-1%
220 3.9K
0.001 B
1.4
R3705
3.3
C3653
NR3603
4D03WGJ0000T5E
NR3604
4D03WGJ0000T5E
DPG4
DPG5
DPG6
DPG7
C3711
3.3
5
5
3.3
0.1 F
R3706
1.8
4
0
C3658
3.3
D3628
3.3
6
5.0
R3708
31
DPG0
DPG1
DPG2
DPG3
3.3
GND V_OUT V_ADJ
6.3V 220 V-S
C3649
0.001 B
3.3
2
C3645
3.3
NR3602
4D03WGJ0000T5E
V_IN
1
0.1 F
3.3
V_C
6.3V 100 V-S
C3626
0.1 F
0
C3634
3.3
4
1.8
NR3606
4D03WGJ0000T5E
0.001 B
2.8
DPR4
DPR5
DPR6
DPR7
3.3
3.3
C3708
3.3
NR3605
4D03WGJ0000T5E
0.001 B
6
4.5
4
0
W1023
5
1.9
0.7
R3701
3.3
3.3
GND V_OUT V_ADJ
1K
+-1%
R3704
220
FROM/TO HDMI MICON2
HDMI_SW
SW
CSDA
HDMI_H
C3709
0
2
680 +-1%
3.3
V_IN
1
10
3.3
V_C
0.1 F
R3703 R3702
3.3
BLM18BB600SN1
32
DPR0
DPR1
DPR2
DPR3
6.3V 100 V-S
C3635
120
3.3
C3659
0.001 B
0
B3605 DDCK
0.1 F
3.3
R3689
W1022
C3710
3.3
C3657
Q23
OGND
CLK48B
GND
VCC
INT
RESET#
SCDT
NC
TEST
XTALVCC
AGND
REGVCC
R1X2+
XTALIN
Q22
XTALOUT
R1X2-
DGND2
Q21
FROM/TO MICOM
6.3V 100 V-S
Q20
109 OVCC
GND
HDMI_H
DPB4
DPB5
DPB6
DPB7
0.001 B
0.1 F
73 DGND
AVCC
P.CON+9V
DS
C3712
0
3.3
C3615
AGND
1.8
EC31QS04
HSYNC
VCC
NR3601
4D03WGJ0000T5E
D3629
OGND
VSYNC
R1X1+
3.3
HDMI_VNREG+5V
3.3V_REG
IC3602
BA00BC0WFP
EC31QS04
OVCC
GND
3.3
C3627
DACOVCC
R1X1-
109 110 111 112 113 114 115 116 117 118 119 120 121 122 123 124 125 126 127 128 129 130 131 132 133 134 135 136 137 138 139 140 141 142 143 144
DACAVCC
VREF
DACAGND
RSET
COMP
DACGNDR
AnRPr
DACVCCR
DACGNDG
DACVCCG
AnGY
DACGNDB
AnBPb
DACVCCB
DACDGND
DACDVCC
GND
VCC
OGND
OVCC
Q19
0 3.2 3.4 3.3 3.3 0 NC 0 3.3 3.3 2.9 1.8
CSCL
3
H_INT
NC
DDVS
B3604
HCB2012K-600T25
16V 10 V-S
0.1 F
C3707
C3706
16V 10 V-S
0.1 F
C3705
C3704
16V 10 V-S
NC
C3703
1M
VDD3
B3613
HCB2012K-600T25
16V 10 V-S
R3698
0
C3702
X3602
0 1.7
33
0 1.8 0 NC1.8
R3700
0 3.3 3.3 3.3 3.3 3.3 3.3 0
W1012
0
4.7K
0
JG3612
0
0.01 B
0 1.8
C3698
0 3.3 3.2
28.322MHz
0 1.8
F
0.1 F
CSDA
AVCC
0.1 F
C3611
44
CSCL
Q18
C3690
10V 47 V-S
DSDA1
AGND
3.3
HDMI+5V
73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100 101 102 103 104 105 106 107 108
0.1 F
C3688
0.1
DSCL1
Q17
0.01 B
R3699
DVI_A_IN_L
DSDA0
R1X0+
C3689
43
DSCL0
Q16
3.3
SCK
WS
SDO
2.5 D
H_INT
G 3.3
RXT1_RST
RXT0_RST
RXT_RST#
2
BUFFER
Q3607
KTK5132E S 2.1
R3678
RX_INT
B
R1X0-
FROM/TO REGULATOR
30
DPB0
DPB1
DPB2
DPB3
3.3
4.7K
B
0.001
OGND
0.1 F
BUFFER
Q3614
KTC3875S_Y_RTK
5.4
6
0.001
C3652
C3686
R3635
1 B
DDVS
DDHS
DDCK
0.001 B
1K
MMZ1608R102CT
3.0
ODCK
AVCC
RX_INT
C3701
2
AGND
RXT_RST#
8.5
R3634 C3651
2.4
OVCC
18P CH C3697
B3621
3.0
BUFFER
Q3621
KTC3875S_Y_RTK
33 DDHS
0.1 F
L
1 B
22uH
NLCV32T
8.5
Q15
R1XC+
C3696
R3681
L
2
1K
R
3
R3633 C3650
P.CON+9V
R1XC-
33
HDMI AUDIO IN
J3601
MSJ-2000B_AG(O87)
1
R
C3687
B3622
MMZ1608R102CT
3
SW
C3656
L3623
Q14
AVCC
R3697
3
Q13
C3693
2
0
ANTSTO
Q12
18P CH
C3694
D2+
3.3
L3605
ACM2012D-900-2P
HDMI CONNECTOR
DC1R019JDA
3.3
GND
HDMI_I/F
IC3605
SiI9021CTU
PVCC1
0.001
B
D2-S
0.001 B
4
PGND
C3695
2
1
3.3
3
VCC
AGND
NC
D2-
C3655
2
Q11
DVCC2
3
L3606
ACM2012D-900-2P
0
Q10
R0X2+
0.001 B
D1+
3.3
4
R0X2-
VCC
D1-S
4
3.3
VCC
Q9
GND
5
1
0.001 B
Q1
AVCC
C3700
D1-
3
3.3
Q0
Q8
OGND
6
2
33 DDVS
R3617
DPR0
DPR1
DPR2
DPR3
DPR4
DPR5
DPR6
DPR7
1
Q7
0.001 B
D0+
1K
7
C3630
L3607
ACM2012D-900-2P
R3686
D0-S
0
4
R3684
8
1
180K
D0-
3.3
3.3
3
R3687
9
2
220K
CLK+
0.001 B
1K
10
L3608
ACM2012D-900-2P
3.3
4
R3683
CLK-S
C3628
1
180K
11
0
AVRL161A1R1NT
2
AGND
OVCC
3.3
B3602
NC
CLK-
3.3
3
OVCC
MCLKOUT
0.001 B
D3626
NC
4
R0X1+
MCLKIN
3.3
5
R0X1-
33
C3692
0.001 B
3.3
C3624
6
Q6
33
0.1 F
C3605
7
OGND
R3629
JG3608
AVRL161A1R1NT
12
2
C3685
0
3.3
8
AVCC
WS
0
D3627
13
R3669
7
JG3613
Q5
R3696
SCL
DPG0
DPG1
DPG2
DPG3
DPG4
DPG5
DPG6
DPG7
100K
0 3.3 3.3 3.3
AGND
33
15
0 3.3 3.3 3.3
R0X0+
SCK R3625
SDA
0
0
GND
JG3611
16
3.3
C3607
0 3.3
36 DGND
33
GND
3.3
R0X0-
33
17
3
L3604
ACM2012D-900-2P
0 3.3
1 DE
SCK
3.3
0.001 B
0
35 DVCC
AVCC
SD1/NC
0
C3623
0 3.3
Q4
WS R3626
2
3.3
3.3
4
0
AGND
SD0
3.3
0.001 B
0 3.3
Q3
SDO R3627
C3622
0
Q2
SD2/NC
0
3
0 1.8 1.8
R0XC+
JG3609
2
R3714
B3603
HCB2012K-600T25
R0XC-
GND
3.3
D2-S
(CP3601)
3.3
AVCC
VCC
3.3
0.001 B
4
1
DET
3.3
0
C3621
0
0.001 B
0.001 B
PVCC0
R1PWR5V
3.3
3
D2+
100K
36 35 34 33 32 31 30 29 28 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9
3.3
R0PWR5V
C3602
C3606
L3602
ACM2012D-900-2P
POWER
0.01 B
R3695
C3721
C3720
16V10 V-S
4
2
0 1.8 3.2 3.2 3.1 3.1 3.1 3.1 3.3 3.3 3.3
MUTEOUT
1
0.1 F
C3718
4
3
2
C3609
0.1 F
L3603
ACM2012D-900-2P
18
1
5
6
7
8
R3609
470K
1
C3717
47K
R3693
R3690
2.2K
5
6
7
8
D
HCB2012K-600T25C3604
EEP_ROM
IC3609
BR24L02F-WE2
3
1
19
1
470K
2
0
3.3
SW
Q3619
KTC3875S_Y_RTK0
R3679
B3601
L3601
ACM2012D-900-2P
14
3
3.3
4
D2-
CP3603
4
G
0
3.3
220K
1
0
BUFFER
Q3617
KTK5132E
0.001
B
16V100 V-S
2
A0
S
5.0
RSPDIF
D1-S
D1+
3
R3710
D1-
4
A1
VCC
0
0.001 B
D0-
WP
0
JG3601
9
A2
33
CLK+
5
4.8
GND
SCL
R3712
10
D0-S
4.9
SDA
C3699
CLK-S
D0+
4.8
D
OVCC
11
7
2.9
BUFFER
Q3615
S KTK5132E
3.2
3.3
3.3
BUFFER
Q3618
KTK5132E
OGND
CLK-
8
D 5.0
1
12
0
3.3
SW
Q3613
KTC3875S_Y_RTK0
DVCC
NC
0
C3691
NC
13
3.3 S
G
47
14
0
0.1 F
SCL
A0
0.001 B
C3614
15
47
VCC
0
72 71 70 69 68 67 66 65 64 63 62 61 60 59 58 57 56 55 54 53 52 51 50 49 48 47 46 45 44 43 42 41 40 39 38 37
SDA
5.0
R3709
10
A1
HCB2012K-600T25
C3613
GND
16
W852
2.2K
17
6
R3685
POWER
BUFFER
Q3616
S KTK5132E
3.2
10
5
R3601
G
470K
1K
R3621
18
G
3.3
R3610
6
HDMI CONNECTOR
CP3601 DC1R019JDA
(CP3603)
19
DET
WP
0
D 5.0
3.3
1K
R3716
0.1 F
4.9
A2
JG3610
47
2.2K
GND
SCL
SD3/NC
R3606
0
SDA
2.2K
47
AVRL161A1R1NT
C3722
BUFFER
S 3.2
Q3604
KTK5132E
R3630
R3688
AVRL161A1R1NT
D3603
R3607
47K
R3605
0.1 F
D3601
5.0
G3.3
R3694
7
R3608
UDZS5.6B
C3633
5.0 D
R3692
UDZS5.6B
D 5.0
G
3.3
BUFFER
3.2 S Q3603
KTK5132E
470K
D3604
RB160L-40
D3600
RB160L-40
D3602
EEP_ROMIC3606 BR24L02F-WE2
5.0
DPB0
DPB1
DPB2
DPB3
DPB4
DPB5
DPB6
DPB7
4.7K
R3600
FROM/TO ADC1
VDD5_PS
D3630
8
NOTE: THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME
OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE
1
NOTE:THE DC VOLTAGE AT EACH PART WAS MEASURED
WITH THE DIGITAL TESTER WHEN THE COLOR BROADCAST
WAS RECEIVED IN GOOD CONDITION AND PICTURE IS NORMAL.
1
PCBDS0
CEE156
A
H-35
B
C
D
E
F
G
H
H-36
A
B
C
D
E
F
G
H
HDMI MICON2 SCHEMATIC DIAGRAM
8
8
(SCALER PCB)
4.7K
6
NC
7
UC_SCL
8
UC_SDA
9
4.6
0
NC
1
5.0
NC
5.0
NC
5.0
NC
0
6
VIDEO_SEL
AUDIO_SEL
G
S
D
DDVS
C3723
3.3
39
100P CH
37
38
4.7K
RXT_RST#
NC
P_SEL
AKM_DIF0
26
27
28
29
30
31
32
33
5.0 NC5.0 NC5.0 NC1.5 NC1.4 NC 5.0
0 NC3.4 NC
0
5.0
5
R3652
4.7K
R3654
4.7K
4.7K
R3649
4.7K
0.1 F
NC
25
0
C3647
EA-/VPP
36
NC
24
5.0
10K
35
ALE/PROG-
23
SDO
R3647
R3632
34
PSEN-
1.3
33
R3717
MUTE_CTL
40
0
NC
5.0
NC
PROGRAM
HDMI MICON
0
IC3611
NC
NC
SST89E58RD2-40-C-TQJE(HD201)
5.0
VCC
5.0
21 NC
AKM_PD
AKM_ACKS 35
3.3
22 RXT0_RST
RX1_RST
RX2_RST 34
5.0
R3648
100
41
5.0
LEVEL SHIFT
Q3620
KTK5132E 0
0
5.6K
42
V_SYNC
R3718
14
43
CSCL
NC
2
3
44
4.6
4
CSDA
RXD
0
RESET
NC
NC
CEC
12
NC
1.24 4.9
6
5
15
13
7
H_SYNC
GND
SCK
5.0
8
NC 43
22
JG3605
DDVS
RXT_RST#
2.5
NC 44
NC
5.0
NC
9
13 AKM_SMUTE
1.2
NC
5.0
H_INT
R3653
C3646
0.1 F
WS
DAC_A-L
HDMI_SW
DAC_A-R
4
7
W969
W970
0
NC
NC
D 4.6
BUFFER
Q3606
S KTK5132E
CSDA
5
NC
NC
NC
3.0
NC
H_INT
12 RX2_INT
16
4.7K
R3639
G
5
X1
17
CSCL
4.7K
R3637
VDD3
GND
X2
18
18P CH
3.3
2.4
5.0
10
19
C3643
SW
4
R3631
4.7K
3.0
20
18P CH
X3601
11.0592MHz
100CT01101
2.7
21
C3642
3.3 G
FROM/TO INTERFACE_HDMI IC
3
EN
RST1_RST
0.1 F
C3637
5.0
NC
UC_SDA
BUFFER
Q3605
3.0 S KTK5132E
2
TX
TXD
8.2K
R3645
2.7
UC_SCL
D 4.6
1
RX
RX1_INT
4.7K
R3644
NC
4.9
GND
6
VCC
UDZS3.3B
11
RXT_RST#
CP3604
A2001WV2-9P
D3609
P3.3/INT1-
4.7K
R3643
HDMI+5V
0.1 F
0.1 F
C3640
C3639
FROM/TO REGULATOR
R3628
4.7K
R3619
C3641
2.2K
16V 10 V-S
4.6
R3641
4.6
D3613
UDZS3.3B
C3638
SDA
0
0.1 F
GND
SCL
8
A2
WP
5.0
7
0
A1
VCC
6
5.0
A0
5
4.7K
0
2
0
1
EEPROM
IC3608
BR24L32F-WE2
3
7
4
R3640
W957
4
RXT1_RST
RXT0_RST
FROM/TO MICON
HDMI_SW
FROM/TO STEREO
CP3602 (CP901)
A2001WV2-4P
4 HDMI_I2SSCK/MCKL
HDMI_I2SSDO
2
HDMI_I2SWS
1
GND
W1024
W839
BLM18BD102SN1
B3612
BLM18BD102SN1
2
2
NOTE: THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME
OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE
1
A
H-37
RXT1_RST
3
3
B3606
RXT0_RST
3
B
C
D
E
NOTE:THE DC VOLTAGE AT EACH PART WAS MEASURED
WITH THE DIGITAL TESTER WHEN THE COLOR BROADCAST
WAS RECEIVED IN GOOD CONDITION AND PICTURE IS NORMAL.
F
G
PCBDS0
CEF156
1
H
H-38
A
B
C
D
E
F
G
H
ASIC SCHEMATIC DIAGRAM
8
8
(DIGITAL PCB)
C2584
0.1 B
1.2
C2585
0.1 B
1.2
C2586
0.1 B
1.2
C2411
1B
1.2
C2412
0.1 B
1.2
C2413
0.1 B
1.2
C2414
C2415
C2416
C2417
C2418
C2419
C2420
C2587
0.1 B
1.2
0.1 B
1.2
1B
1.2
0.1 B
1.2
0.1 B
1.2
0.1 B
1.2
1B
1.2
0.1 B
1.2
C2588
0.1 B
1.2
C2589
0.1 B
1.2
C2590
0.1 B
1.2
C2421
0.1 B
1.2
C2422
0.1 B
1.2
VDDP
K5
E25
VDDC
VDDP
L5
F5
VDDC
VDDP
J5
G5
VDDC
G26
VDDC
H26
VDDC
E13
VDDR3
E14
VDDR3
E18
VDDR3
E19
M5
VDDC
VDDR3
E22
M26
VDDC
VDDR3
E23
N5
VDDC
VDDR3
E26
U5
VDDC
VDDR3
F26
V5
VDDC
VDDR3
P5
V26
VDDC
VDDR3
R5
W26
VDDC
VDDR3
W5
AA5
VDDC
VDDR3
Y5
AB5
VDDC
VDDR3
AC5
AD26 VDDC
VDDR3
AD5
AE5
VDDC
VDDR3
AF6
AE26
VDDC
VDDR3
AF7
AF5
VDDC
VDDR3 AF10
AF8
VDDC
VDDR3 AF11
AF9
VDDC
VDDR3 AF14
AF12
VDDC
VDDR3 AF15
AF13
VDDC
VDDR3 AF19
AF17
VDDC
VDDR3 AF20
AF18
VDDC
VDDR3
AF22
VDDC
3.3
C2593
3.3
C2594
0.1 B
0
0.1 B
0
0.1 B
0
0
VDDR3
VDDC
VDDC
C2592
0
0
L26
AF21
3.3
0.1 B
VDDR3
J26
K26
3.3
C2428
0.1 B
3.3
C2429
0.1 B
0
3.3
C2430
0.1 B
0
3.3
C2431
0
0.1 B
0
3.3
C2432
0.1 B
0
3.3
C2433
0.1 B
0
3.3
C2434
0.1 B
0
3.3
C2435
1B
0
3.3
C2595
0.1 B
0
3.3
C2596
0.1 B
0
3.3
C2597
0.1 B
0
3.3
C2598
0.1 B
0
3.3
C2436
3.3
C2437
3.3
C2438
3.3
C2439
3.3
C2599
3.3
C2600
3.3
C2601
3.3
C2602
0.1 B
0
0.1 B
0
0.1 B
0
1B
0
0.1 B
0
0.1 B
0
0.1 B
0
0.1 B
0
3.3
C2440
0.1 B
0
3.3
C2441
0.1 B
0
3.3
C2442
0.1 B
0
3.3
C2443
1B
0
0
0
3
VDDC18_RIGHT
N26
VDDC18_TOP
E15
VDDC18_BOTTOM AF16
FROM FLASH
VDDC18_LEFT
T5
1.8
C2444
0.1 B
1.8
C2445
0.1 B
0
1.8
C2446
0.1 B
0
1.8
C2447
0
1B
0
0
DTV_RESET
0
0
0
FROM AV OUT
0
0
DTV_RESET
0
VSS
VSS
P13
K14
VSS
VSS
P14
K15
VSS
VSS
P15
K16
VSS
VSS
P16
K17
VSS
VSS
P17
K18
VSS
VSS
P18
K19
VSS
VSS
P19
K20
VSS
VSS
P20
K21
VSS
VSS
P21
L10
VSS
VSS
R10
L11
VSS
VSS
R11
L12
VSS
VSS
R12
L13
VSS
VSS
R13
L14
VSS
VSS
R14
L15
VSS
VSS
R15
L16
VSS
VSS
R16
L17
VSS
VSS
R17
L18
VSS
VSS
R18
L19
VSS
VSS
R19
L20
VSS
VSS
R20
L21
VSS
VSS
R21
M10
VSS
VSS
T10
M11
VSS
VSS
T11
M12
VSS
VSS
T12
M13
VSS
VSS
T13
M14
VSS
VSS
T14
M15
VSS
VSS
T15
M16
VSS
VSS
T16
M17
VSS
VSS
T17
M18
VSS
VSS
T18
M19
VSS
VSS
T19
M20
VSS
VSS
T20
M21
VSS
VSS
T21
N10
VSS
VSS
U10
N11
VSS
VSS
U11
N12
VSS
VSS
U12
N13
VSS
VSS
U13
N14
VSS
VSS
U14
N15
VSS
VSS
U15
N16
VSS
VSS
U16
N17
VSS
VSS
U17
N18
VSS
VSS
U18
N19
VSS
VSS
U19
N20
VSS
VSS
U20
N21
VSS
VSS
U21
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
V12
VSS
VSS AA12
V13
VSS
VSS AA13
V14
VSS
VSS AA14
V15
VSS
VSS AA15
V16
VSS
VSS AA16
V17
VSS
VSS AA17
V18
VSS
VSS AA18
V19
VSS
VSS AA19
V20
VSS
VSS AA20
V21
VSS
VSS AA21
W10
VSS
VSS
A2
W11
VSS
VSS
A29
W12
VSS
VSS
B1
W13
VSS
VSS
B2
W14
VSS
VSS
C3
W15
VSS
VSS
D4
W16
VSS
VSS
E5
W17
VSS
VSS
AJ1
W18
VSS
VSS AJ30
W19
VSS
VSS
W20
VSS
VSS AK29
W21
VSS
Y10
VSS
Y11
VSS
Y12
VSS
Y13
VSS
Y14
VSS
Y15
VSS
Y16
VSS
Y17
VSS
AK2
0
C2454 10P CH
0
C2451
0
0.001 B
0
0
4.7
0
NC
0
C2456
0
20P CH
38
0
C2457
0
18P CH
0
B2403
R2402
0
BLM18BD151SN1
4.7
VSS
Y21
VSS
Y30
VSS
0
1.7
FE_OSC_AVDD
1.8
0
0
C2448
NC
AH8
NC
TDI
AJ7
NC
TDO AK6
OSC_AVDD
NC
DINT
AG8
NC
TAPSEL
AH7
NC
RESETb
B14
7
OSC_AVSS
G27
OSC_GUARD
H27
OSC_CLK
D21
FE_XTALIN
D20
FE_XTALOUT
B20
FE_OSC_AVDD
A20
FE_OSC_AVSS
C20
FE_OSC_GUARD
B21
FE_OSC_CLK
3.3
RESETOUTb C14
XILLEON_RESET_IN#
NC
6
TESTEN
D15
0
TESTEN
RSVD M2
(TEST MODE)
NC
NMI
NC
A14
R2414
1K
5
0
0
B2404
R2404
0
BLM18BD151SN1
4.7
1.8
MPVDD
0
AF29 MPVDD
AE29 MPVSS
RSVD(0) AF2
NC
RSVD(1) AF1
NC
RSVD(2) AG4
NC
RSVD(3) AG3
NC
RSVD(4) AG2
NC
RSVD(5) AG1
NC
RSVD6 AH1
NC
RSVD7 AH2
NC
RSVD11 H29
NC
RSVD12 H30
NC
10 C
R2405
4.7
R2406
0
1.8
FPVDD
4.7
G30
G29
VPVDD
VPVSS
0
D19
FPVDD
D18
FPVSS
W4
PMIVDD
Y4
PMIVSS
4
10 C
R2403
BLM18BD151SN1 4.7
0
C2455
1.8
VPVDD
10 C
B2402
1.8
PMIVDD
0
3
10 C
0
0
0
0
R2417
0
XILLEON_RESET_IN#
100
RESET IC
IC2405 BD5229G-TR
0
0
0
2
FROM POWER2
DTV_RESET
OSC1.8V
FDCFE1.8V
CORE_1.2V
+1.8V
+3.3V
F29
NC
TCK
10 C
BLM18BD151SN1
0
1.5
0
BLM18BD151SN1
0
XTALOUT
25.140MHz
+-15ppm
0
C2452
Y20
G28
NC
0
B2406
VSS
1.2
0
0
C2450
Y19
1.8
0
B2405
VSS
F28
AK7
TMS AG9
TRSTb
100
1uH
L2402
NLV25T
B2401
R2401 2.2uH
OSC_AVDD
C2449
Y18
R24071.1
L2401
BLM18BD151SN1
XTALIN
VDDC_1.8V
3.24
VOUT
3.24
VDD
GND
0
CT
1.85
NC
0
NC
2
B
1.2
VDDC
3.3
C2591
K13
0
F27
0.001
1.2
0.1 B
E24
0
0
0.8
B
0.1 B
C2583
H5
1B
P12
VSS AA11
55.474MHz
+-15ppm
C2466
C2410
VDDP
C2427
VSS
VSS
37
C2453 10P CH
0
C2465
1.2
VDDC
0
3.3
VSS
V11
0
0.01
0.1 B
E21
3.3
K12
VSS AA10
VSS
5
1.2
E10
P11
V10
X240H
4
1.2
1B
E9
VDDP
0.1 B
0
VSS
0
1
0.1 B
C2408
VDDP
VDDC
C2426
0.1 B
VSS
0
0
2
C2407
VDDC
E20
C2425
K11
0
3
1.2
E17
3.3
P10
0.1 B 4.7K
1.2
0.1 B
E8
VSS
C2464 R2416
0.1 B
C2406
VDDP
VSS
0.001
B
1.2
VDDC
K10
C2459
0.1 B
E16
0
C2460
1.2
E7
0
0.1 B
0.001 B
0.1 B
C2405
C2409
4
1.2
VDDP
0.1 B
C2424
C2461
C2404
0.1 B
VDDC
C2423
3.3
0.001 B
1.2
E12
3.3
C2462
1B
E6
0.001 B
1.2
C2401
VDDP
C2463
0.1 B
C2403
5
1.2
C2582
C2402
6
0.1 B
VDDC
0.001 B
C2581
E11
C2458
1.2
0.001 B
1.2
0.1 B
100
0.1 B
C2505
ATSC/CLEAR CABLE ASIC
IC2401 (4/14 OSC)
ATSC/CLEAR CABLE ASIC
IC2401 (3/14 VSS) X240H
R2418
C2500
ATSC/CLEAR CABLE ASIC
IC2401 (2/14 VSS) X240H
X2401
7
ATSC/CLEAR CABLE ASIC
(1/14 VDD)
IC2401 X240H
X2402
HS2401
763WAA0351
D_GND
1
NOTE: THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME
OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE
A
H-39
B
C
D
1
PCBDH0
CEF169
NOTE:THE DC VOLTAGE AT EACH PART WAS MEASURED
WITH THE DIGITAL TESTER WHEN THE COLOR BROADCAST
WAS RECEIVED IN GOOD CONDITION AND PICTURE IS NORMAL.
E
F
G
H
H-40
A
B
C
D
E
F
G
H
SDRAM SCHEMATIC DIAGRAM
8
8
2.6
MEM_DQ18
2.6
MEM_DQ19
2.6
MEM_DQ20
2.6
MEM_DQ21
2.6
MEM_DQ22
2.6
MEM_DQ23
2.6
MEM_DQ24
4
2.6
MEM_DQ25
2.6
MEM_DQ26
2.6
MEM_DQ27
2.6
MEM_DQ28
2.6
MEM_DQ29
2.6
MEM_DQ30
2.6
MEM_DQ31
2.6
MDQM0
2.6
MDQM1
2.6
MDQM2
2.6
MDQM3
2.6
MQS0
2.6
U27
DQA_15
AH30
DQA_16
AG27
DQA_17
AH28
DQA_18
AJ29
DQA_19
AH27
DQA_20
AG26
DQA_21
AK27
DQA_22
AJ28
DQA_23
AH24
DQA_24
AK25
DQA_25
AG23
DQA_26
MAA_3
MAA_9
AE30
AE27
MAA_11 AE28
WEAb
Y27
CSAb_1
Y28
CLKA
Y29
CLKAb
W29
MEMTEST AF28
AG24
DQA_28
MEMVMODE_1AF27
AH25
DQA_29
AJ24
DQA30
DQMAb_0
W28
DQMAb_1
VDDR1
P26
VDDR1
R26
VDDR1
AJ27
T26
VDDR1
W30
VDDR1
Y26
DQMAb_2
AK26
DQMAb_3
R29
QSA_0
VDDR1 AB26
V30
QSA_1
VDDR1 AF24
VDDR1 AA26
3
MQS1
2.6
MQS2
2.6
MQS3
2.6
3.3
FROM POWER2
3.3
3.3
+3.3V
R2429
22
MAD3
2.6
R2435
22
MAD9
0.2
0
2.6
R2437
22
0.17
0.28
MAD11
C2483
2.6
R2443
22
2.6
MRWE#
0.15
0.1 B
0
NC
2.5
R2447
22
MCLK
2.4
R2448
22
MCLK#
0
0
0
NC
2.6
C2484
0.1 B
MQS1
R2457
C2485
AH26
QSA_2
VDDR1 AF25
AJ26
QSA_3
VDDR1 AF26
VDDR1 AK28
U26
PESD
AC26
PESD
VDDR1 AG30
AF23
PESD
VSS AF30
0
R2425
2.6
15 +-1% 15 +-1%
0
R2449
R2452
MDQM1R2420
15 +-1%
R2454
1K
R2455
1K
2.6
C2468
2.6
C2469
0.1 B
2.6
C2470
0.1 B
2.6
C2471
0.1 B
2.6
C2472
0.1 B
2.6
C2473
0.1 B
2.6
C2474
0.1 B
0.1 B
C2486
2.6
C2475
0.1 B
2.6
C2476
0.1 B
6.3V 100 TZV
2.6
C2477
0.1 B
2.6
C2478
0.1 B
2.6
0
56 1.0
0
NC
2.6
0
NC
0
56
MRWE#
2.3
MCAS#
1.8
MRAS#
2.2
MCS0#
MAD14
0.84
0
NC
1.35
MAD13
1.4
MAD10
0.1
MAD0
0
MAD1
0
MAD2
0.2
MAD3
1.2
2.6
VDD
VSS
DQ0
DQ15
VDDQ
VSSQ
DQ1
DQ14
DQ2
DQ13
VSSQ
VDDQ
DQ3
DQ12
DQ4
DQ11
VDDQ
VSSQ
DQ5
DQ10
DQ6
VSSQ
DQ7
NC
VDDQ
LDQS
NC
DQ9
VDDQ
DQ8
NC
VSSQ
UDQS
NC
VDD
VREF
NC
VSS
LDM
UDM
WE
CK
CAS
CK
RAS
CKE
CS
NC
NC
A12
BA0
A11
BA1
A9
AP/A10
A8
A0
A7
A1
A6
A2
A5
A3
A4
VDD
VSS
0.1 B
C2487
C2494
0
0.3
MEM_DQ23
MEM_DQ20
MEM_DQ22
MEM_DQ21
NR2413
4D02WGJ0560TCE
MEM_DQ19
MEM_DQ18
MEM_DQ16
MEM_DQ17
NR2412
4D02WGJ0560TCE
2.6
0.2
0.1 B
C2495
0
0.12
2.6
0
0.1 B
0.2
0.1
C2490
2.6
0
0
0.16
0.1 B
0.27
0.1
C2496
0
0.15
2.6
0.12
0.1 B
0
0.1
C2491
2.6
0.14
0.95
0
NC
1.25
1K
R2459
R2460
1K
C2497
0.1 B
MQS0
MQS3 R2461
C2488
56
MEM_VREF
0
0
0
0
NC
2.6
0.1 B
R2458
NC 0
0
0
0.1 B
C2498
0.1 B
R2419
56
56 1.0
0
NC
2.6
0
NC
0
56
MDQM0
R2422
MDQM3
1.11
MCLK#
MRWE#
2.3
1.17
MCLK
MCAS#
1.8
MCKEN#
MRAS#
2.2
MCS0#
2.5
0
NC
0.3
MAD12
0.6
MAD11
MAD14
0.85
0
NC
1.34
0.6
MAD9
MAD13
1.4
1.17
MAD8
MAD10
0.18
1.21
MAD7
MAD0
0
1.15
MAD6
MAD1
0
1.16
MAD5
MAD2
0.2
1.17
MAD4
MAD3
1.1
0
C2499
2.6
VDD
VSS
DQ0
DQ15
VDDQ
VSSQ
DQ1
DQ14
DQ2
DQ13
VSSQ
VDDQ
DQ3
DQ12
DQ4
DQ11
VDDQ
VSSQ
DQ5
DQ10
DQ6
DQ9
VSSQ
VDDQ
DQ7
DQ8
NC
NC
VDDQ
VSSQ
UDQS
LDQS
NC
NC
VDD
VREF
NC
VSS
LDM
UDM
WE
CK
CAS
CK
RAS
CKE
NC
CS
NC
A12
BA0
A11
BA1
A9
AP/A10
A8
A0
A7
A1
A6
A2
A5
A3
A4
VDD
VSS
0
0.3
0
0.12
0.3
C2502
2.6
0.1 B
0.44
0.35
0
0.14
5
0.4
C2503
2.6
0.27
0.1 B
NC 0
0
0.92
0
NC
1.25
R2462
MQS2
C2504
56
MEM_VREF
0.1 B
0
0
R2421
1.11
56
MDQM2
MCLK#
1.18
MCLK
2.5
0
NC
0.2
MCKEN#
0.6
MAD11
0.5
MAD9
1.17
MAD8
1.21
MAD7
1.1
MAD6
1.16
MAD5
1.17
MAD4
4
MAD12
0
0.1 B
3
C2479
C2467
0.1 B
2
0
0.1 B
MEMVMODE_0AG28
T30
2.6
1.3
MVREFS AG29
1.3
MVREFD AH29
DQA_27
DQA_31
2.6
0.1 B
NR2401
4D02WGJ0102TCE
AJ25
AG25
0.2
34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66
MEM_DQ17
DQA_14
2.6
0.1 B
C2482
1
MEM_DQ16
2.6
U28
C2481
MAD14
MCKEN#
MRAS#
MCAS#
2
2.6
DQA_13
2.6
AB29
2.6
AB30
2.6
AA29
2.6
AA30
3
MEM_DQ15
U29
MAA_14
CKEA
RASAb
CASAb
4
2.6
DQA_12
6
HY5DU561622ETP-D43
5
MEM_DQ14
DQA_11
U30
IC2403
6
MEM_DQ13
2.6
V29
7
256Mbit DDR SDRAM
256Mbit DDR SDRAM
IC2402
HY5DU561622ETP-D43
NR2405
4D02WGJ0220TCE
7
2.6
DQA_10
8
MEM_DQ12
DQA_9
W27
MAD7
MAD8
MCS0#
MAD13
33 32 31 30 29 28 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9
MEM_DQ11
2.6
V27
NR2404
4D02WGJ0220TCE
MEM_DQ24
MEM_DQ26
MEM_DQ25
MEM_DQ27
2.6
2.6
AB28
2.6
AB27
2.6
AA28
2.6
AA27
NR2411
4D02WGJ0560TCE
MEM_DQ10
MAA_7
MAA_8
CSAb_0
MAA_13
MEM_DQ31
MEM_DQ29
MEM_DQ28
MEM_DQ30
2.6
DQA_8
NR2410
4D02WGJ0560TCE
MEM_DQ9
DQA_7
V28
MEM_DQ2
MEM_DQ3
MEM_DQ1
MEM_DQ0
2.6
NR2409
4D02WGJ0560TCE
MEM_DQ8
DQA_6
T29
MEM_DQ6
MEM_DQ5
MEM_DQ7
MEM_DQ4
2.6
DQA_5
T28
MAD2
MAD6
MAD1
MAD12
NR2408
4D02WGJ0560TCE
MEM_DQ7
T27
NR2403
4D02WGJ0220TCE
34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66
2.6
DQA_4
2.6
AD29
2.6
AD30
2.6
AC29
2.6
AC30
1
MEM_DQ6
R30
MAA_2
MAA_6
MAA_1
MAA_12
2
MEM_DQ5
2.6
DQA_3
3
2.6
DQA_2
R28
4
MEM_DQ4
R27
MAD4
MAD10
MAD0
MAD5
5
2.6
NR2402
4D02WGJ0220TCE
6
2.6
MEM_DQ3
DQA_1
2.6
AD28
2.6
AD27
2.6
AC28
2.6
AC27
7
MEM_DQ2
P27
MAA_4
MAA_10
MAA_0
MAA_5
MEM_DQ8
MEM_DQ9
MEM_DQ11
MEM_DQ10
2.6
DQA_0
8
5
MEM_DQ1
P28
33 32 31 30 29 28 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9
6
2.6
NR2407
4D02WGJ0560TCE
7
MEM_DQ0
NR2406
4D02WGJ0560TCE
(5/14 SDRAM)
ATSC/CLEAR CABLE ASIC
IC2401
X240H
MEM_DQ13
MEM_DQ12
MEM_DQ14
MEM_DQ15
(DIGITAL PCB)
6.3V 100 TZV
2
D_GND
+1.8V
+2.6V
VDDR_MEM
PCBDH0
CEF169
NOTE: THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME
OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE
1
A
H-41
B
C
NOTE:THE DC VOLTAGE AT EACH PART WAS MEASURED
WITH THE DIGITAL TESTER WHEN THE COLOR BROADCAST
WAS RECEIVED IN GOOD CONDITION AND PICTURE IS NORMAL.
D
1
E
F
G
H
H-42
A
B
C
D
E
F
G
H
FLASH SCHEMATIC DIAGRAM
8
8
NFIO0
NFIO1
NFIO2
NFIO3
NFIO4
NFIO5
ATSC/CLEAR CABLE ASIC
X240H
IC2401
(7/14 FLEX BUS)
NFIO6
ATSC/CLEAR CABLE ASIC
X240H
IC2401
(6/14 FLASH)
NFIO7
(DIGITAL PCB)
C2509
0.1 B
B6
NC
48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33 32 31 30 29 28 27 26 25
N28
NFRY_BYb
NC
E2
FAD(5)
FSTB
A4
NC
N27
NFCEb(0)
D1
NC
3.3
F4
3.3
E3
3.2
D2
FAD(6)
FRD
D7
NC
FAD(7)
FWE
C6
NC
FAD(8)
FRDYb
B5
NC
FINTR(0)
H4
J27
NFIO(8)
FINTR(1)
F1
NC
NC
J28
NFIO(9)
FINTR(2)
G2
NC
NC
K27
NFIO(10)
FINTR(3)
H3
NC
NC
K28
NFIO(11)
FINTR(4) AK11
NC
NC
L27
NFIO(12)
NC
L28
NFIO(13)
NC
M27 NFIO(14)
NC
M28 NFIO(15)
NC 0
NC 0
NC
NC
6
0 NC
NC
NC 0
NC
0 NC
NC
0.1
0 NC
NC
NC 0
NC
C2508
0 NC
NC
0
IO(0)
2.2K
0 NC
NC
0
IO(1)
WP
R2481
3.3
IO(2)
0
IO(3)
ALE
WE
NC 0
NC 0
0
NC
CLE
NC 0
0
NC 0
NC 0
3.3
NC 0
0
0
NC
C2507
6.3V 22 TZV
DTV_RESET
5
0
NC 0
0
NC 0
9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24
NC
NC
NC 0
8
3.3
FAD(15)
7
ROMSO_NFWE#
C4
6
0
NC
5
ROMSCK_NFALE
M29 NFIO(7)
NC
FAD(14)
4
0 NC
3.3
B3
3
R2482
B
10K
NFCLE
NC
NC
NFIO(6)
VSS
NC
L30
NC
NC
D6
2
0 NC
C5
FCEb(3)
VCC
FCEb(2)
FAD(13)
VSS
FAD(12)
C2
VCC
D3
NC
1
0
NC
NFIO(5)
NC
NFIO(4)
L29
NC
K30
NC
NC
NC
NC
B4
0 NC
3.3
A3
FCEb(1)
0 NC
FCEb(0)
FAD(11)
NC
FAD(10)
E4
CE
C1
NC
3.3
NC
NFIO(3)
CS_NF1#
NFIO(2)
K29
FAD(9)
IO(4)
J30
FAD9
RE
NFIO(1)
3.3
J29
ROMSI_NFRE#
NFIO(0)
IO(5)
FAD7_8
H28
R/ B
3.3
NC
FALE(1)
3.3
NFIO7
A5
FAD(4)
IO(6)
3.3
FALE(0)
F3
SE /GND
NFIO6
FAD(3)
NC
IO(7)
3.3
G4
NFREb
NC
NFIO5
NC
P29
0 NC
0
NFIO4
3.3
M30 NFCEb(1)
7
NC
3.3
NC
NC
3.3
NFIO3
NC
D8
0 NC
NFIO2
C7
FBE(1)
NC
3.3
FBE(0)
FAD(2)
NC
NFIO1
FAD(1)
E1
NFRY_BY#
TO ASIC
3.3
F2
NC
10K
6
NFIO0
NC
NFWEb
0 NC
ROMCS_NFCE0#
NFALE
N29
NC 0
3.3
N30
JG2457
NC
NFRY_BY#
D5
NC
3.3
FCLK
NC
3.3
ROMSI_NFRE#
FAD(0)
NC
CS_NF1#
G3
0 NC
3.3
NC
0 NC
3.3
NFCLE
FLASH MEMORY
HY27US08281A-TP
ROMSCK_NFALE
ROMSO_NFWE#
FCLK
P30
IC2406
3.3
R2470
7
NFCLE
5
JG2407
JG2408
FAD9
JG2409
FAD7_8
4
JG2424
0.1 B
A0
VCC
8
0
JG2412
ROMSCK_NFALE
JG2413
ROMSI_NFRE#
3.3
JG2414
SCL
VSS
SDA
7
A2
0
6
WP
2.8
I2C_CLKA
5
2
3
3.3
A1
4
DTV_RESET
0
2.8
I2C_DATA
4
JG2411
ROMSO_NFWE#
EEPROM
IC2404 BR24L64F-WE2
1
C2506
ROMCS_NFCE0#
JG2415
FROM POWER2
0
R2464
10K
3
3
+3.3V
2
NOTE: THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME
OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE
1
3.3K
3.3K
R2484
R2485
D_GND
ATSC/CLEAR CABLE ASIC
IC2401 (8/14 I2C BUS) X240H
I2C_CLKA
R2592
100
3.3
I2C_DATA
R2593
100
3.3
AG20 I2CCLKA
AK21 I2CDATAA
SPI_CLK
G1
NC
SPI_IN
J4
NC
SPI_OUT
H2
NC
NC
AJ20 I2CCLKC
SPI_CS0
J3
NC
NC
AH20 I2CDATAC
SPI_CS1
H1
NC
2
NOTE:THE DC VOLTAGE AT EACH PART WAS MEASURED
WITH THE DIGITAL TESTER WHEN THE COLOR BROADCAST
WAS RECEIVED IN GOOD CONDITION AND PICTURE IS NORMAL.
1
PCBDH0
CEF169
A
H-43
B
C
D
E
F
G
H
H-44
A
B
C
D
E
F
G
H
FRONT END SCHEMATIC DIAGRAM
8
8
(DIGITAL PCB)
ATSC/CLEAR CABLE ASIC
AG6
NC
DVSYDATA(3)
AJ3
NC
NC
V3
DVIDATA(5)
DVSYDATA(4)
AH4
NC
NC
V4
DVIDATA(6)
DVSYDATA(5)
AG5
NC
NC
U1
DVIDATA(7)
DVSYDATA(6)
AJ2
NC
NC
U2
DVIDATA(8)
DVSYDATA(7)
AH3
NC
NC
U3
DVIDATA(9)
NC
U4
DVIDATA(10)
NC
T1
DVIDATA(11)
NC
R2
DVIDATA(12)
DVIDATA(14)
TDATA(1)
L3
NC
NC
P1
DVIDATA(15)
TDATA(2)
K1
NC
TDATA(3)
L4
P3
DVIDATA(17)
TDATA(4)
K2
NC
NC
P4
DVIDATA(18)
TDATA(5)
J1
NC
NC
N1
DVIDATA(19)
TDATA(6)
K3
NC
NC
N2
DVIDATA(20)
TDATA(7)
J2
NC
N4
DVIDATA(22)
TCLKA
K4
NC
NC
M1
DVIDATA(23)
TSTRTA
M4
NC
DVICLK
R1
NC
T2
DVIHSYNC
NC
T3
DVIVSYNC
NC
FDC_CRX
D11
NC
FDC_DRX
D10
NC
MPEG_D0
A6
NC
MPEG_D1
B7
NC
MPEG_D2
C8
NC
MPEG_D3
A7
NC
MPEG_D4
D9
NC
AG18
DVODATA(2)
E30
VI_ATBP
NC
AJ18
DVODATA(3)
D24
VI_REFM
NC
AH18
DVODATA(4)
C24
VI_REFP
C2701
NC
0.1 B
A17
B2412
FS_AVDD
FDCFE1.8V
BLM18BD151SN1
C2702
0
0.1 B
C2534
FDC_AGC
VI_IN7
0.1 B
VI_IN6
C27
1.8
7
NC
AG17
DVODATA(5)
NC
AK18
DVODATA(6)
AH17
AG16
AK17
AJ17
0.1 B VI_REFM 0.3
C2520
VI_REFP
C2512
0.1 B
VIBYPASS11.2
C2513
0.1 B
VIBYPASS01.2
C2514
10 C
C2515
10 C
DVODATA(7)
1.8
DVODATA(8)
1.8
DVODATA(9)
ADC1.8V
DVODATA(10)
NC
AH16
DVODATA1(1)
NC
AG15
DVODATA1(2)
NC
AK14
DVODATA(13)
NC
AJ14
DVODATA(14)
NC
AH14
DVODATA(15)
NC
AG14
DVODATA(16)
NC
AK13
DVODATA(17)
NC
AJ13
DVODATA(18)
NC
AH13
DVODATA(19)
NC
AK12
DVODATA(20)
NC
AG13
DVODATA(21)
NC
AJ12
DVODATA(22)
NC
AH12
DVODATA(23)
1.3
B2408
BLM31PG601SN1
ADC1.8V
B2407
1.8
ADC0_AVDD
0
0
0
1.8
ADC1_AVDD
BLM31PG601SN1
1.8
1.8
0
0
0
E29
VI_BYPASS1
B28
VI_BYPASS0
D27
ADC0_AVDD
MPEG_D5
B8
NC
C26
ADC0_AVDD
MPEG_D6
C9
NC
D25
ADC0_AVDD
MPEG_D7
A8
NC
A26
ADC0_AVSS
MPEG_CLK
B9
NC
B25
ADC0_AVSS
MPEG_SYNC B10
NC
B27
ADC0_AVSS
MPEG_DATA_EN C10
NC
A9
NC
C30
ADC1_AVDD
E28
ADC1_AVDD
MPEG_ERR
6
FROM/TO AV OUT
C2537
R2498
0.1 B
100
C2538
R2499
0.1 B
100
5
T_FAT_IFP
D29
FAT_IFP
A28
FAT_IFM
A27
ADC1_AVDD
0.7
X_FAT_IFP
0.7
X_FAT_IFN
T_FAT_IFN
DNI
B29
ADC1_AVSS
B30
ADC1_AVSS
AGC_SDMX A15
C28
ADC1_AVSS
AGC_SDM1 B15
NC
3.3
X_FAT_IFAGC
R2495
C2542
1K
0.1 B
FAT_IFAGC
DVIDATA(21)
N3
NC
NC
D28
NC
NC
NC
NC
4
DVIDATA(16)
NC
NC
VI_ATBM
NC
R4
P2
C18
F30
NC
NC
NC
C19
FS_AVSS
DVODATA(1)
NC
L2
FS_AVDD
VI_IN5
DVODATA(0)
NC
TDATA(0)
VI_IN4
C29
AK19
NC
DVIDATA(13)
D30
NC
390
DVSYDATA(2)
DVIDATA(4)
R3
NC
0
R2497
DVIDATA(3)
V2
NC
B18
AJ19
NC
5
A18
FS_DVSS
NC
0.1 B
V1
NC
AK3
FS_DVDD
VI_IN3
FDCFE1.8V
BLM18BD151SN1
NC
NC
DVSCLKA
VI_IN2
A25
NC
0.1 B
AH5
C25
NC
B2411
FS_DVDD
NC
1.8
NC
C2531
DVSYDATA(1)
NC
NC
0.1 B
6
DVIDATA(2)
W1
AJ4
B19
C2532
NC
DVSYDATA(0)
0.1 B
DVIDATA(1)
C2521
W2
C2517
NC
A19
FS_OUTN
0.1 B
DVIDATA(0)
FS_OUTP
VI_IN1
0.1 B
W3
VI_IN0
B26
C2522
NC
ATSC/CLEAR CABLE ASIC
IC2401 (9/14 DVO) X240H
X240H
D26
C2518
ATSC/CLEAR CABLE ASIC
IC2401 (10/14 DVI)
NC
NC
C2535
7
X240H
0.1 B
IC2401(11/14 FRONT END)
TVLDA
L1
NC
TERA
M3
NC
B2410
+3.3V
3.3
A21
VI_AVDD33
4
BLM18BD151SN1
C2516
NC
A23
FDC_IFP
GPIOC(0)
D16
0.1 B
NC
A22
FDC_IFM
GPIOC(1)
C16
3.3
X_TUNER_SDA
3.3
X_TUNER_SCL
NC
NC
AJ16
DVOCLK0
NC
B23
FDC_BYPASS
GPIOC(2)
B16
NC
AK16
DVOCLK1
NC
B24
FDC_REFP
GPIOC(3)
A16
NC
AH15
DVODE
FDC_REFM
GPIOC(4)
D17
NC
NC
AJ15
DVOHSYNC
FDC_AVDD
GPIOC(5)
C17
NC
NC
AK15
DVOVSYNC
A24
NC
1.8
D23
1.8
C21
1.8
D22
FDC_AVDD
GPIOC(6)
B17
FDC_AVDD
GPIOC(7)
A10
GPIOC(8)
C11
GPIOC(9)
B11
GPIOC(10)
D12
GPIOC(11)
A11
NC
GPIOC(12)
C12
NC
GPIOC(13)
B12
NC
GPIOC(14)
A12
NC
GPIOC(15)
D13
NC
DVIDE
T4
NC
AGC_SDM2 C15
FDCFE1.8V
B2409
FDC_AVDD
3.3
RF_SW
NC
3.3
SD-H
0.1 B
0.1 B
C2533
C2519
BLM31PG601SN1
3
0
0
0
0
C23
FDC_AVSS
B22
FDC_AVSS
C22
FDC_AVSS
E27
VI_GUARD
FROM POWER2
NC
3
3.3
AFT_1
3.3
AFT_2
+3.3V
2
2
+1.8V
D_GND
NOTE:THE DC VOLTAGE AT EACH PART WAS MEASURED
WITH THE DIGITAL TESTER WHEN THE COLOR BROADCAST
WAS RECEIVED IN GOOD CONDITION AND PICTURE IS NORMAL.
NOTE: THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME
OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE
PCBDH0
CEF169
1
1
A
H-45
B
C
D
E
F
G
H
H-46
A
B
C
D
E
F
G
H
AV OUT SCHEMATIC DIAGRAM
17
18
19
20
GND
IF OUT1
IF OUT2
15
16
14
RF_SW
GND
13
TU I2C CLK
8
IF AGC
12
TU I2C DATA
9
10
I2SSDO_IN
11
8
I2SSCLK_OUTA
I2SWS_IN
7
5
SPDIF OUT
I2SSDO_OUTA
4
RX (X240)
I2SWS_OUTA
3
TX (X240)
6
2
DTV POWER
20
(CP5802)
CP2404 125607220W3
1
DTV_RESET
19
16
AFT_2
15
CVBS OUT
18
14
GND
AFT_1
13
GND
SD-H
12
V OUT
AUDIO MUTE-L 17
11
8
GND
7
GND
GND
6
GND
9
5
REG +5V
10
4
UNREG+4V
U OUT
3
UNREG+4V
Y OUT
2
UNREG+4V
4
UNREG+5V
3
GND
FROM/TO TUNER
2
USBP
(CP5801)
CP2403 125607220W3
1
UNREG+5V
1
+5V
USBN
CP2405 YKF45-0036N
FROM/TO FIRM UPDATE
I2SSCLK_IN
(DIGITAL PCB)
8
C2625 47PCH
7
T_FAT_IFN
T_FAT_IFP
FAT_IFAGC B2424 BLM18BD102SN1
B2423 BLM18BD102SN1
RF_SW
TUNER_SDA B2422 BLM18BD102SN1
TUNER_SCL B2421 BLM18BD102SN1
I2SCLK_INC
I2SWS_INC
I2SDATA_INC
I2SDATA_OUTA
I2SCLK_OUTA
C2621 47PCH
C2622 47PCH
I2SWS_OUTA
SPDIF_OUTA
DTV_ON-H
TX_[X240] B2425 BLM18BD102SN1
RX_[X240] B2426 BLM18BD102SN1
47P CH47P CH
DTV_RESET
B2427 BLM18BD102SN1
B2415 BLM18BD102SN1
47P CH47P CH
C2612 C2624
AFT_2
AFT_1
SD-H
B2414 BLM18BD102SN1
CVBS_OUT
B2413 BLM18BD102SN1
V[PR]_OUT
U[PB]_OUT
0.1 B
47P CH
Y_OUT
C2630
C2608
B3410 BLM18BD151SN1
15K
C2609
47P CH
C2611 C2623
AT+5V
15K
R2534
C2606 0.1 B
UNREG+4V_MB3406 BLM31PG601SN1
UNREG+4V B3408 BLM31PG601SN1
R2533
USB_P_A
AT+5V
USB_N_A
7
C2605 0.1 B
UNREG+5V B3407 BLM31PG601SN1
NC
FROM/TO FRONT END
6
V[PR]_OUT
R2527
T_FAT_IFN
FAT_IFAGC
75 +-1%
C2572
47P CH
C2564
47P CH
R2523
75 +-1%
L2414 NLV25T
0.47uH
6
T_FAT_IFP
34
X_TUNER_SDA
X_TUNER_SCL
AJ6 I2SWS_IND
I2SSD_OUTB AJ11
NC
NC
AK5 I2SSD_IND
I2SSOSCK_OUTB AG12
NC
SPDIF_OUTA AJ9
4
G
AC1
B
3.4
RSET
AE1
C_R
AB2
Y_G
AA2
COMP_B AA1
4.7K
R2508
R2SET
AB1
VDDDI
VDD2DI
Y2
AF3
VSSDI
VSS2DI
Y1
1 QRSET R2529
R2409
0 DAC4_R
680
R2530
33
33
0 DAC5_G
R2531
33
1 TRSET
R2532
R2410
680
33
1.8
1.8
Y3
AVSSQ
A2VSSQ
AA4
1.8
0
R2537
A1VDD
A2VDD
AC4
AD3
AVSSN
A2VSSN
AA3
AE3
AVSSN
A2VSSN
AB3
0.1 B
C2560
0.1 B
C2557
C2556
0
B
75 +-1%
R2525
R2524
47P CH
NC
AK24 USBPB
CTSAb AK22
NC
AJ23 USBNB
RTSAb AG21
NC
3
AK23 USB_OVRCUR
NC
AG19 IRRXDA
RDB AJ22
NC
AK20 IRTXDA
TDB AH22
NC
AH19 IRBIDB
NC
A13
CAPT1
RDC C13
NC
D14
COMP1
TDC B13
R2535
15K
R2536
15K
TWIRE_TXDB
3.3
TWIRE_RXDC
3.3
TWIRE_TXDC
2
1
NOTE:THE DC VOLTAGE AT EACH PART WAS MEASURED
WITH THE DIGITAL TESTER WHEN THE COLOR BROADCAST
WAS RECEIVED IN GOOD CONDITION AND PICTURE IS NORMAL.
C
TWIRE_RXDB
+3.3V
USB_N_B
USB_P_B
B
D_GND
A
NC
TDA AH21
1
10 C
C2552
10 C
C2551
C2553
BLM18BD151SN1
USB_N_A
USB_P_A
B2416
DAC_2.5V
NOTE: THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME
OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE
RDA AJ21
AG22 USBNA
0
VDDC_1.8V
+2.6V
3.3
AH23 USBPA
4.7
4.7
4.7
4.7
DAC2_AVDD
2.6
R2541
AF4
2.6
R2540
AB4
R2539
A2VDD
R2538
A1VDD
AT+5V
H-47
C2570
USBB_N 0
UNREG+4V
1
C2569
USBB_P 0
0.1 B
AE4
C2575
DAC1_AVDD
UNREG+4V_M
+3.3V
47P CH
C2562
USBA_P 0
DAC_AVDDQ
0.1 B
C2576
B2418
BLM18BD151SN1
UNREG+5V
+1.8V
X240H
100K
DTV_ON-H
2
47P CH
ATSC/CLEAR CABLE ASIC
IC2401 (14/14 USB/SERIAL)
DAC_VDDI
C2574
A2DDQ
4
0 DAC6_B
0.1 B
AVDDQ
0.1 B
AD4
S 3.3
LEVEL_SHIFT
3.3
Q2406
G
KTK5132E
D 3.3
TX_[X240]
AC3
C2559
BLM18BD151SN1
1 B
4.7K
S 3.3 4.7K
LEVEL_SHIFT
3.3
Q2403
G
D 3.3
KTK5132E
FROM/TO POWER2
DAC_AVDDQ
1 B
R2509
B2419
C2555
R2512
TWIRE_RXDC
RX_[X240]
0.47uH
USBA_N 0
TWIRE_TXDC
CVBS_OUT
33
TUNER_SDA
3
36
L2413 NLV25T
0 DAC3_COMP R2528
C2573
AE2
0.1 B
1 B
C2558
100
R2440
TUNER_SCL
DAC_VDDI
C2554
BLM18BD151SN1
C2561
DTV_RESET
1.1 DAC2_B
0.1 B
B2417
TO ASIC
1.1 DAC1_G
4.7K
100
R2441
AD2
COMP AD1
75 +-1%
AC2
R2515
X_TUNER_SDA
X_TUNER_SCL
NC
1.1 DAC0_R
75 +-1%
NC
R
U[PB]_OUT
R2526
NC
R2521
L2411 NLV25T
0.47uH
47P CH
I2SSCK_OUTB AH11
35
C2571
AK4 I2SSCK_IND
5
47P CH
NC
NC
AFT_2
SD-H
NC
HSYNC2_OUT AG10
VSYNC2_OUT AK8
I2SWS_OUTB AK10
75 +-1%
22
22
R2519
NC
3.3
Y_OUT
0.47uH
47P CH
I2SSD_OUTA AG11
NC
C2563
I2SSOSCK_OUTA AJ10
AJ5 I2SSD_INC
VSYNC_OUT AH9
75 +-1%
AH6 I2SWS_INC
3.3
R2520
I2SSCK_OUTA AH10
NC
75 +-1%
3.3
AG7 I2SSCK_INC
HSYNC_OUT AJ8
AFT_1
33
L2412 NLV25T
R2522
3.3K
R2516
3.3K
3.3
3.3
BLM18BD151SN1
3.3
+3.3V
3.3
3.3
B2420
1.0
R2506
G
1.5
S
D
I2SDATA_INC
3.3
1.7
R2514
LEVEL_SHIFT
Q2401 KTK5132E
G
2.6
I2SWS_OUTA AK9
S
D
I2SWS_INC
2.3
ATSC/CLEAR CABLE ASIC
IC2401 X240H (13/14 VIDEO ENCODER)
3.3K
5
3.3
G
LEVEL_SHIFT
Q2404 KTK5132E
S
D
I2SCLK_INC
X240H
R2517
LEVEL_SHIFT
Q2407 KTK5132E
R2518
22
RF_SW
ATSC/CLEAR CABLE ASIC
IC2401 (12/14 I2S AUDIO)
D
PCBDH0
CEF169
E
F
G
H
H-48
A
B
C
D
E
F
G
H
POWER2 SCHEMATIC DIAGRAM
8
8
D3407
RB520S-30-TE61
C3413
10 B
B
C3411
0.1
0.22
9 10 11 12 13 14 15 16
1
2
3
5
6
10.3
5.4
7
0
5.1
5.2
W808
5.2
10 B
C3412
100
TO ASIC
R3427
4.7uH
ELLCTV4R7N
0.047
1/4W
D3408
CORE_1.2V
CORE_1.2V
BLM31PG391SN1L
6
+1.8V
D_GND
R3428
C3416
C3415
0.047
1/4W
6.3V 100 TZV
S1
G1
B3401
D1
D1
D2
D2
4 3 2 1
2.7 1.3 3.5 0
B3402
+3.3V
RSX301L-30 BLM18PG330SN1D
3.3K
SW
0
Q3403
KTC3875S_Y_RTK
S2
0
2.9
R3401
10K
SW
0
Q3404
KRC103SRTK
G2
R3405
DUAL FET
Q3405
SP8K3
C3407
4.5
5 5 1.3 1.3
5 6 7 8
6.3V 470 CV-EX
4.7K
R3406
6
0
L3401
2V 150 CD
100
R3430
1 B
3.3
R3414
0.001 B
C3410
C3408
0
R3429
7
2.9
8
3.3
DC/DC CTL
IC3401
AL1042
4
3.3
1.3
5.6
C3409
0.8
0
15K
1.2K
+-1%
5.6K
+-1%
R3412
12K +-1%
7
1.2
15P CH
R3413
R3410
R3411
(DIGITAL PCB)
TO FLASH
+3.3V
D_GND
TO FRONT END
+3.3V
5
5
+1.8V
IC3404
5
3.18
2
V_OUT V_ADJ
6
3.25
0
4
1.8
EN
5
Vin
1
1.25
2
3.18
4
D3403
GND Vout Vadj
6
3
4
5
0
2.6 1.27
4
TO AV OUT
+3.3V
1K +-1%
+1.8V
+2.6V
B
C3435
6.3V 220 SJV
C3434
120
3
0.1
R3425
R3426
820 +-1%
R3424
1K +-1%
6.3V 100 SJV
B
C3432
B
D_GND
+3.3V
D_GND
1
C3430
C3431
0.1
B
0.1
C3429
6.3V 330 TZV
C3428
680 +-1%
R3423
R3422
10
R3421
B
+2.6V
0.1
1 B
C3426
C3425
6.3V 220 SJV
C3421
R3419
39
560 +-1%
B
R3420
C3420
0
6.3V 100 SJV
B
C3419
3.1
0.1
AT+5V
DTV_ON-H
0.1
POWER_SW
Q3406
KRC103SRTK 5.3
UNREG+4V
C3418
UNREG+4V_M
GND
+1.8V
UNREG+5V
3
V_IN
1
1.26
C3424
R3418
FROM/TO AV OUT
4
3.3
SJV
0
V_C
16V47
6
4
C3423
2
3.18
V_OUT V_ADJ
B
1
GND
0.1
V_IN
1K +-1%
V_C
D3404
4
BA7810HFP
D3405
R3434
5.6K
DH
EC11FS2-TE12L
REG+2.6V
REG+1.8V
BD7820FP
1.8K
IC3403
R3433
DH
EC31QS04
BA00BC0WFP
220
IC3402
EC31QS04
REG+3.3V
R3432
5.3
EC31QS04
+5V
POWER_SW
Q3407
KRA101SRTK
D3402
5.2
D3406
5.2
EC11FS2-TE12L
D_GND
TO SDRAM
D_GND
+3.3V
+3.3V
+1.8V
+1.8V
+2.6V
+2.6V
2
2
NOTE:THE DC VOLTAGE AT EACH PART WAS MEASURED
WITH THE DIGITAL TESTER WHEN THE COLOR BROADCAST
WAS RECEIVED IN GOOD CONDITION AND PICTURE IS NORMAL.
NOTE: THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME
OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE
THESE PARTS MARKED BY
CAUTION:SINCE
CRITICAL FOR SAFETY,USE ONES
DESCRIBED IN PARTS LIST ONLY
ARE
PIECES REPAREES PAR UN
ETANT
ATTENTION:LES
DANGEREUSES AN POINT DE VUE SECURITE
CAUTION: DIGITAL TRANSISTOR
CAUTION: DIGITAL TRANSISTOR
N’UTILISER QUE CELLS DECRITES
DANS LA NOMENCLATURE DES PIECES
1
1
PCBDH0
CEF169
A
H-49
B
C
D
E
F
G
H
H-50
A
B
C
D
E
F
G
H
OPERATION/SIDE JACK/FILTER SCHEMATIC DIAGRAM
8
8
(SIDE JACK PCB)
(OPERATION PCB)
R4493
SIDE_V_IN
6
SIDE_S_C
7
SIDE_S_Y
8
SIDE_S_L
1
H
2
E
NC
2
1K 1/4W 22uH
C6543
0.001 B
1
2
H
L4227
E
6
3
1K 1/4W 22uH
RED
SIDE AUDIO R JACK
J4209
AV-5A-67H
R
R6505
6
3
V
NC
SIDE AUDIO L JACK
J4208
AV-5A-68H
L4200
1
5
R6504
E
GND
H
SIDE_A_IN_L
4
NC
3
7
3
GND
L
NC
2
B4208
W4BRH3.5X6X1.0X2
NC
7
WHITE
FROM/TO AV SWITCH2
CP4200 (CP4201)
A2001WV2-8P
1
SIDE_A_IN_R
YELLOW
75 1/4W
SIDE VIDEO JACK
J4207
AV-5A-66H
FROM/TO JACK
C6542
(CP2200) CP2203
A2001WR2-3P
3
KEY A
R2205
390 1/4W
KEY B
W855
GND
0.001 B
2
1
R6509
B4209
W4BRH3.5X6X1.0X2
CD2203
CU23A001
75
1/4W
R6506
6
2
4
5
3
1
S4-25SZ
Y J4206 C
C2209
0.01 B
EVQ21505R
POWER ON/OFF
SW2205
5
EVQ21505R
VOL UP/DOWN
SW2203
560 1/4W
5
R6508
B4210
C2204
1/4W
0.01 B
EVQ21505R
VOL DOWN/UP
SW2202
EVQ21505R
CH DOWN/UP
SW2206
EVQ21505R
EVQ21505R
CH UP/DOWN
SW2204
INPUT SELECT
SW2201
W4BRH3.5X6X1.0X2
75
W858
W857
W856
PCBD90
4
R2201
R2202
5.6K 1/4W
2.2K 1/4W
R2203
1.2K 1/4W
4
CEE134
R2206
R2204
820 1/4W
390 1/4W
PCB270
D3901
FH3901
D3900
EYF-52BCY
EYF-52BCY
F3900
8A125V
T8A H 250V
2
8A 125V
ENE471D-10A
FH3900
D3902
3
DSS-272M
(FILTER PCB)
ENE271D-10A
CEE133
PH3900
1 003P-2100
1
PCBD00
CEE131
3
PH3901
003P-2100
W859
W860
2
or250V
CAUTION:FOR CONTINUED PROTECTION AGAINST FIRE HAZARD,
REPLACE ONLY WITH THE SAME TYPE FUSE 8A 125V (F3900)
CP3900
A3963WV2-3PD
1
2
2
1
8A 125V
UNE PROTECTION CONTINUE LES RISQUES D’INCEIE
ATTENTION:POUR
N’UTILISER QUE DES FUSIBLE DE MEME TYPE 8A 125V (F3900)
CP3901
A3963WV2-3PD
CD3901
CUU33002
CD3900
CUU21001
1
1
CAUTION
:SINCE THESE PARTS MARKED BY
CRITICAL FOR SAFETY,USE ONES
DESCRIBED IN PARTS LIST ONLY
A
H-51
B
ARE
PIECES REPAREES PAR UN
ETANT
ATTENTION:LES
DANGEREUSES AN POINT DE VUE SECURITE
NOTE:THE DC VOLTAGE AT EACH PART WAS MEASURED
WITH THE DIGITAL TESTER WHEN THE COLOR BROADCAST
WAS RECEIVED IN GOOD CONDITION AND PICTURE IS NORMAL.
N’UTILISER QUE CELLS DECRITES
DANS LA NOMENCLATURE DES PIECES
C
D
E
NOTE: THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME
OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE
F
G
H
H-52
E
F
G
H
INTERCONNECTION DIAGRAM
SP303
SP301
SPEAKER
SP302
SPEAKER
SPEAKER
D
4 OHM 10W
(R)
C
SP304
4 OHM 10W
(L)
B
SPEAKER
A
8
9
9
SCART1_B
GND
21
21
10
10
GND
SCART1_G
SIDE_S_Y
SIDE_S_C
GND
19
19
12
12
GND
GND
4
5
SIDE_V_IN
SCART1_R
18
18
13
13
SCART1_R
SIDE_V_IN
5
4
GND
17
17
14
14
GND
16
16
NC
14
14
17
17
GND
SCART1_Y
SIDE_A_IN_R
NC
SCART2_SW
13
13
18
18
SCART2_SW
SC2 CVBS_OUT-H 12
12
19
19 SC2 CVBS_OUT-H
11
11
20
20
POWER_FAIL
POWER_ON-H 10
POWER_ON-H
21
22
9
9
Y OUT
U OUT
10
10
U OUT
GND
11
11
GND
GND
12
12
GND
V OUT
13
13
V OUT
GND
14
14
GND
GND
15
15
GND
CVBS OUT
16
16
CVBS OUT
AUDIO MUTE-L 17
18
18
SD-H
AFT(0)
19
19
AFT_1
AFT(1)
20
20
AFT_2
3
2
DTV_RESET
1
1
DTV_RESET
DTV POWER
2
2
DTV POWER
TX (X240)
3
3
TX (X240)
RX (X240)
4
4
RX (X240)
SPDIF OUT
5
5
SPDIF OUT
I2SSOCK_OUTA 6
6
I2SSOCK_OUTA
I2SSDO_OUTA 7
7
I2SSDO_OUTA
I2SWS_OUTA
8
8
I2SWS_OUTA
I2SSCLK_OUTA 9
9
I2SSCLK_OUTA
I2SSDO_IN
10
10
I2SSDO_IN
I2SWS_IN
11
11
I2SWS_IN
I2SSCLK_IN
12
12
I2SSCLK_IN
TU I2C DATA
13
13
TU I2C DATA
TU I2C CLK
14
14
TU I2C CLK
RF_SW
DIGITAL PCB
PCBDH0
CEF169
CP5802
REMOCON IN
GND
AT+5V
4
4
AT+5V
STANDBY LED
5
5
STANDBY LED
P.ON LED
6
6
P.ON LED
KEY A
3
GND
17
17
GND
IF OUT2
NC
28
28
SW_YUV1/2
HP_IN
2
2
29
29
HP_IN
LIGHT CTL/PSU_5VD 1
1
30
30 LIGHT CTL/PSU_5VD
DVD/AV3_SW 29
YELLOW
L
V
H
2
WHITE
YELLOW
WHITE
COAXIAL JACK
J4202
E
1
7
RESET
6
CHIP_SELECT
5
1
1
DVD/AV3_SW
4SI_SCL
4
4SI_SDA_IN
3
DTUNER_H
28
28
2
2
DTUNER_H
2
NC
1
GND
1
GND
2
25
25
5
5
7 +5V
DTUNER_RX
GND
24
24
6
DTUNER_RX
GND
DTUNER_TX 23
23
7
DTUNER_TX
22
22
8
8
GND
DTUNER_RESET_L21
21
9
9
DTUNER_RESET_L
GND
20
20
10
10
GND
SW_AUDIO_R(PC) 19
19
11
11 SW_AUDIO_R(PC)
GND
18
18
12
12
GND
SW_AUDIO_L(PC)17
17
13
13
SW_AUDIO_L(PC)
16
16
14
14
STEREO_RESET 15
15
15
15
NC
SCART3_SW 14
14
16
16
NC
SCART_AUDIO_SW13
13
17
17 SCART_AUDIO_SW
SDA1
12
12
18
18
SDA1
SCL1
11
11
19
19
SCL1
GND
10
10
20
20
GND
UC_SCL
DTUNER_POWER 9
9
21
21
DTUNER_POWER
UC_SDA
GND
8
8
22
22
GND
DTUNER_SD_H7
23
23
6
7
6
24
24
GND
SWITCH_CVBS 5
5
25
25
4
4
26
26
SWITCH_VIDEO_Y 3
3
27
27 SWITCH_VIDEO_Y
GND
2
2
28
28
SWITCH_VIDEO_C 1
1
29
29 SWITCH_VIDEO_C
GND
GND
CP901
HDMI_I2SSCK/MCKL 4
19 IF_OUT 1
20 IF_OUT 2
CD901
GND
1
EEPROM_SCL
2
EEPROM_SDA 3
IIC_OFF
4
GND
5
4
I2C SCL
5
GND
6
LED control
7
TxOUT0b+
MICON_DATA
CP102
CP3604
9
10
GND
1
GND
11
RX
2
TX
2
RXIN3+
12
STEREO_RESET
TX
3
BUSY
3
RXIN3-
13
SCART3_SW
EN
4
NC
4
TxCLKOUTb+
14
GND
5
VCC
5
TxCLKOUTb-
15
NC
6
CLK
6
RXCLK IN+
16
NC
7
RX
7
RXCLK IN-
17
8
CNVSS
8
GND
18
9
RESET
9
GND
19
GND
10
RXIN2+
20
RXIN2-
21
22
SWITCH_CVBS
TxOUT1b+
TxOUT1b-
GND
RXIN1+
24
RXIN1-
25
GND
26
GND
27
RXIN0+
28
RXIN0-
29
GND
30
GND
31
DTUNER_SD_H
GND
CP3602
4 HDMI_I2SSCK/MCKL
3
HDMI_I2SSDO
HDMI_I2SWS
2
2
HDMI_I2SWS
1
1
GND
HDMI AUDIO IN
TO PANEL
CD7206
PANEL
V801
FILTER
V802
3
23
2
CD2201
24
J3601
4
8
TxOUT0bI2C_READY
1
3
5
3
GND
VCC
HDMI_I2SSDO
GND
I2C SDA
CP101
6
7
GND
6
CP7206
4SI_SDA_OUT
18 IF AGC
23
CP803
AT+3.3V
GNP/INV_DET
16 IF SW
AV PCB
PCBD20
CMF083
29
FFC
CD4203
CP103
DTV_MUTE_L
CP2203 CD2203
1
IF OUT1
3
4
17 IF OUT
2
20
1
3
3
13 V_OUT
OPERATION PCB
PCB270
CEE133
GND
19
2
D2+
SW_YUV1/2
4
15 SIF
KEY B
19
3
D2-S
SCART1_SW
3
14 +5V
IF AGC
20
4
D2-
27
26
11 AFT
REMOCON PCB
PCBDA0
CEF179
RF_SW
IF OUT2
5
D1+
26
27
27
12 AGC_OUT
16
IF OUT1
6
D1-S
26
4
26
9 SDA
GND
15
GND
7
D1-
5
4
10 SCL
16
18
8
D0+
S_DET
5
27
REMOCON IN
15
18
D0-S
SCALER PCB
PCBDS0
CEF156
GNP/INV_DET
3 B+
3
LCD-H/PDP_RLY
DTV_MUTE_L
8 AGC
2 GND
3
25
6 GND
CP3901
IF AGC
GND
5 TU
1 Vout
2
25
CP4203
NC
OS2251
2
9
6
4 +30V
CP4202_1 CD4202 CP2251
IR-THROUGH 1
IR-THROUGH
1
17 AUDIO MUTE-L
SD-H
CP2404
CP3900
D0-
LCD-H/PDP_RLY 6
VGA-R
Y OUT
DVB_FAN_ON-H
VGA-G
GND
24
1
8
24
VGA-B
8
10
7
2
GND
11
CLK+
7
3
GND
15
DVB_FAN_ON-H
NC
7
16
SCL
12
DGND
7
17
SDA
CLK-S
4
GND
18
GND
LCDON
5
REG +5V
POWER
23
AGND
6
CP3603
19
AGND
6
DET
E
6
REG +5V
FILTER
PCBD00
CEE131
1
3
7
UNREG+4V
2
D2+
2
23
AGND
5
3
D2-S
NC
8
8
5
3 GND
4
D2H1
9
NC
UNREG+4V
PH3901
5
D1+
8
9
UNREG+4V
6
D1-S
LCDON
SCART1_SW
7
13
NC
4
7
D1-
CLK-
DGND
4
8
D0+
1
10
UNREG+4V
1
9
D0-S
4
11
UNREG+4V
10
D0-
AFT_1
DDCD
3
CLK+
22
VGAHS
3
2
21
12
UNREG+4V
11
VCC
22
S_DET
2 +5V
12
21
13
UNREG+5V
1 OOB
NC
2
2
2
1
UNREG+5V
2
UNREG+5V
CLKCLK-S
10
CP2200
1
4
1
1
GND
1
COMMAND TRANSMITTER
TM101
USBP
4
PH3900
CP5801
UNREG+5V
15
9
VGAVS
R
16
SCL
AFT_1
14
3
L
17
SDA
14
DDCC
2
CEE134
POWER_FAIL
DIGITAL/ANALOG TUNER W/NTSC_MPX
TU5801
GND
3
AUDIO IN(DVI1/PC)
J4301
15
6
IR PASS THROUGH
J2275
SIDE JACK
PCBD90
CP4302
1
15 AFT_2/DTV_CVBS
15
R
1
15
15
1
8
16
GND
SCART1_Y
GND
3
SIDE_S_L
AFT_2/DTV_CVBS 16
SIDE_A_IN_L
L
2
2
3
7
KEY A
6
SIDE_S_Y
3
SIDE_S_C
GND
NC
5
2
C
4
3
Y
3
SCART1_G
11
6
CP2403
USBN
11
20
3
1
2
20
18
IN
GND 1
H2
19
POWER
13
NC
SIDE_S_L
DET
14
RED R
22
CP3601
4
OS4202
22
OPTICAL JACK
SCART1_B
CP4201
H1
5
E
WHITE L
GND
AT+5V
8
11
8
1
11
23
H2
AT+5V
23
GND
GND
P.CON+5V
EXT_MUTE-H
10
7
10
24
NC/POWER_ON_H NC
P.CON+5V
24
7
GND
AUDIO_MUTE
9
6
EXT_MUTE-H
6
7
9
25
3
E
GND
25
5VD/LIGHT_CTL
GND
AUDIO_MUTE
6
8
HP_MUTE
7
5
8
5
6
GND
26
6 P.CON+3.8V
26
VS ON/LCDON
7
HP_MUTE
5
6
4
H1
2
1
2
J4201_1
CVBS/AUDIO OUT
GND
4
12 NC/INVERTER_DET NC
11 5
P.CON+3.8V
27
GND
AT3.3V
27
4
AFT
12
5 P.CON+3.8V
3
4
3
7
5
28
4
28
AFT
NC
AT3.3V
NC/ST_BY_H
5VST_BY/AT+5V
4 3
8
P.CON+3.8V
11
3
P.CON+5V
REMOCON IN
3
2
3
STANDBY LED
2
P.CON+5V
1
29
P.CON+9V
1
29
2
30
REMOCON IN
13
2
STANDBY LED 30
GND
10 9
E
P.CON+9V
GND
RLY ON/LCD-H
16
E
CP802
9
ACD/P.FAIL
2
19
INPUT 1/2
J4205
10
1
1
+5V
FFC
CD4204
E
RED
CP4204
E
CP3807
(CP3201)
P.CON12V
1
12VSC
H1 H2
CD3807
8
H1 H2
CP3201
P.CON12V
1
12VSC
AUDIO_IN 4/5
J4204
NC H1
21 20 23 22 17 18 14 15
RED
7
1
E
NC H1
3
WHITE
SOUND GND
2
WHITE
4
H1 H2
5
RED
GND
4
RED
6
6
E
GREEN
SOUND GND
7
SIDE_A_IN_L
5
1
GREEN
3
8
CS_IN 4/5
J4211
J4206
CP2405
BLUE
GND
NC H2 NC H1
R
3
1
1
2
2
CD301
3
2
1
GND
5
H1
KEY B
E
3
E
NC
1
2
H
SIDE AUDIO R JACK
J4209
R
4
7
2
1
30V or 24V
8
3
E
30V or 24V
E
2
GND
6
1
4
E
2
1
2
3
SIDE_A_IN_R
CD4200
H1 H2
2
1
H
2
NC
3
V
NC
H
NC
L
NC
CP4200
5
1
CP3804
SIDE AUDIO L JACK
J4208
6
(CP2203)
GND
SIDE VIDEO JACK
J4207
7
H1 H2
BLUE
5VSC
8
RED
3
9
RED
5VSC
H2
SP OUT R+
2
NC
GND
SP OUT R-
2
CP301
5VSC
SP OUT L-
1
CP303
9VSC
SP OUT L+
CP3803
1
CP3801
7
2
CP3802
1
CD303
8
1
1
NOTE: THIS INTERCONNECTION DIAGRAM IS THE LATEST AT THE TIME
OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE
A
H-53
B
C
D
CAUTION
:SINCE THESE PARTS MARKED BY
CRITICAL FOR SAFETY,USE ONES
DESCRIBED IN PARTS LIST ONLY
E
PIECES REPAREES PAR UN
ETANT
ATTENTION:LES
DANGEREUSES AN POINT DE VUE SECURITE
ARE
N’UTILISER QUE CELLS DECRITES
DANS LA NOMENCLATURE DES PIECES
F
G
H
H-54
WAVEFORMS
TUNER
ADC1
2.0ms
20ns
1.0V
1
2.0V
20µs
1.0V
6
11
SOUND AMP/HEADPHON AMP
2.0ms
500mV
2
STEREO
2.0ms
2.0V
2.0ms
500mV
7
12
AV SWITCH2
2.0ms
500mV
3
100µs
2.0V
2.0ms
500mV
8
13
MICON
2.0ms
2.0V
4
100µs
50ns
500mV
2.0V
9
14
SCALER
2.0ms
2.0V
5
20µs
500mV
20µs
500mV
10
15
NOTE: The following waveforms were measured at the point of the corresponding
balloon number in the schematic diagram.
I-1
WAVEFORMS
20µs
500mV
1.0ms
500mV
16
21
26
20µs
1.0V
ADC1
20µs
500mV
5µs
10µs
500mV
2.0V
17
27
22
ADC1
20µs
5µs
200mV
2.0V
18
5µs
500mV
23
28
LVDS
20µs
200mV
10ms
100mV
19
24
5µs
500mV
29
JACK
20µs
200mV
20
INTERFACE_HDMI IC
1.0ms
1.0V
20µs
1.0V
25
30
NOTE: The following waveforms were measured at the point of the corresponding
balloon number in the schematic diagram.
I-2
WAVEFORMS
20µs
1.0V
31
20µs
1.0V
36
ASIC
20µs
1.0V
10ns
50mV
32
37
AV OUT
5µs
2.0V
33
20ns
50mV
38
5µs
2.0V
34
5µs
2.0V
35
NOTE: The following waveforms were measured at the point of the corresponding
balloon number in the schematic diagram.
I-3
MECHANICAL EXPLODED VIEW
223
223 113
213
PCBD00
(FILTER PCB ASS'Y)
104A
223
104A
224 221
104B
224
223
133
124
221
104A
211
121
125
205
227
214
224
125
221
223
124
224
124
221
121
142
111
223
210
141
202
125
102E
220
208
203
205
102F
220
102A
203
218 214 112
202
102E
202
214
111
102B
214
102D
218
202
210
141
212
103B
137
102G
205
103A
125
220
220
102E
102C
214
214
138
138
220
102E
108B
108A
139
217 202
142
V801
214
214
104A
104
208208
220
212
209
102E
201
117
131
220
220
214 214 214
214
214
108
201
102
202
202
202
226
202
122
202
202
203
203
203
137
122
107B
138
106B
119
V802
132
116
215
222
101H
101E
203
203
222
101H
101E
219
101F
114
127
219
203
101I
134
101G
107
215
129
215
215
215
215
222
203 101H
101I
101E
219
222
101C
101H
101E 203
101A
203
123
223
109A 109B
109
223
PCBDS0
(SCALER PCB ASS'Y)
136
135
120
PCBDH0
(DIGITAL PCB ASS'Y)
223
223 135
206
223
115
129
105A
223
216
101D
216
PCB270
216
(OPERATION PCB ASS'Y)
101J
203
133
110
140
216
203
204 204
223
203
PCBDA0
(REMOCON PCB ASS'Y)
204
223
223
219
101F
101G
203
223
138
223
223
138
223
138
228
101K
203
105B
101L
203
203
202
107A
215
215
203
130
214 202
215
101B
204
103
228
PCBD90
(SIDE JACK PCB AS'Y)
202
225
105C
203
119 203
119
207
106
105
103B
203
106A
214
214
202
203
118
202
214 202
202
202
203
203
119
119 203
202
202
202
101
138
216
130
203
203
203
203
223
138
126
223
223
PCBD20
(AV PCB ASS'Y)
203
134
128
NOTE: Speaker is not included in Front Cabinet Ass'y.
J-1
J-2
MECHANICAL EXPLODED VIEW
(PACKING DIAGRAM)
149
149
155
149
149
148
158
150, 151, 152, 153, 154, 156,
CD3820, TM101, TR3820
145
145
157
143
144
146
146
147
J-3
MECHANICAL REPLACEMENT PARTS LIST
Location No.
TSB P/N
Reference No.
Description
101
101A
101B
101C
101D
101E
101F
101G
101H
101I
101J
101K
101L
72784200
72784165
72784166
72784167
72783966
72783968
72784208
72781222
72794733
72795699
72783965
72798569
72783969
7A7010191A
701WPJ1414
702WPA1216
702WPA1217
713WPA0386
761WPA0431
800WF00065
800WQ0A092
801WR00001
899EFBA002
711WPA0254
7235490037
774WPA0009
FRONT CABI ASS'Y
CABINET,FRONT
COVER,SPEAKER (L)
COVER,SPEAKER (R)
GLASS,LED
HOLDER,SPEAKER
CUSHION
FELT SHEET
DAMPER SPEAKER
WIRING-CLIP
PLATE,REMOCON
BADGE,BRAND
HOLDER CORD
102
102A
102B
102C
102D
102E
102F
102G
72784202
72784207
72784171
72784187
72784188
72783974
72781311
72781991
7A7040011A
7G7610050A
704WPB0016
761WEB0010
761WEB0011
800WRA0008
899000NK4N
89982E42A0
STAND ASS'Y
ANGLE STAND ASS'Y
STAND
FRAME,BOTTOM-L
FRAME,BOTTOM-R
CUSHION,LEG
CABLE CLAMPS
BAND
103
103A
103B
72784201
72784170
72784211
7A7020071A
702WSB0128
800WQ00114
BACK CABI ASS'Y
CABINET,BACK
FELT SHEET
104
104A
104B
72783982
72783992
72783983
7G7520032A
709WPA0043
762WSA0078
ANGLE,PCB ASS'Y
HOLDER,CORD
ANGLE,PCB
105
105A
105B
105C
72783987
72783990
72783988
72783989
7G7610045A
761WSB0029
7230008097
7230008140
PLATE,JACK ASS'Y
PLATE,JACK
SHEET,JACK-1
SHEET,JACK-2
106
106A
106B
72783984
72783985
72783986
7A7010192A
711WPA0256
7230008098
PLATE,JACK-SIDE ASS'Y
PLATE,JACK-SIDE
SHEET,JACK(SIDE)
107
107A
107B
72784206
72783992
72784193
7G752A008A
709WPA0043
762WSA0082
SHIELD,MAIN-BOTTOM ASS'Y
HOLDER,CORD
SHIELD,MAIN-BOTTOM
108
108A
108B
72783976
72783978
72783977
7G7610043A
702WPA1218
761WSB0028
COVER,BACK ASS'Y
COVER,CONNECTOR
COVER,BACK
109
109A
109B
72784204
72783994
72795677
7G7520041A
752WSA0555
753WUAA006
SHIELD DIGITAL ASS'Y
SHIELD DIGITAL
SPRING EARTH H/AMP
110
111
112
113
114
115
116
117
118
119
72784179
72784172
72784173
72784001
72784175
72784002
72784003
72784181
72784182
72784184
752WSA0565
705WPA0020
7225490230
7260000353
7230008105
738WPB0077
752WSA0554
752WSA0594
753WEAA003
753WUA0083
SHIELD SCALER
HANDLE BACK
SHEET,RATING
SHEET EARTH MARK
POP LABEL
BUTTON,FRAME
SHIELD,JACK-SIDE
SHIELD,PLATE
SHEET CU
SPRING,EARTH
K1-1
MECHANICAL REPLACEMENT PARTS LIST
Location No.
TSB P/N
Reference No.
Description
120
121
122
123
124
125
126
127
128
129
72783995
72784186
72784226
72784227
72784007
72784189
72784190
72784191
72784192
72784209
752WSA0556
761WEA0008
8965TS2A15
8965TS2A50
761WPA0427
761WPA0445
762WSA0079
762WSA0080
762WSA0081
800WFA0086
DIGITAL SHIELD COVER
FRAME,MAIN
CUSHION W6/H2/L1015
CUSHION W6/H2/L1050
HOLDER,BUSH
HOLDER,CAP-LG
SHIELD,MAIN-L
SHIELD,MAIN-R
SHIELD,MAIN-TOP
CUSHION
130
131
132
133
134
135
136
137
138
139
72784210
72781302
72784221
72781306
72784222
72798807
72781978
72784225
72795699
72784176
800WFA0087
890MP2401A
890MP2401G
8965TS1060
8965TS0640
8965TS1010
8965TS1017
8965TS2550
899EFBA002
7250000606
CUSHION
TAPE 50*35
TAPE 30X12
CUSHION W10/H10/L60
CUSHION W6/H2/L640
CUSHION 65TS10-10(10*10*25)
CUSHION 65TS10-10(17.5*20*14)
CUSHION W6/H2/L550
WIRING-CLIP
SHEET CAUTION
140
141
142
143
144
145
146
147
148
149
72783997
72784018
72795680
72784020
72784021
72784195
72784196
72784198
72784199
72784026
752WSA0587
899ML02111
8995034000
791WHA0117
791WHA0118
792WHA0647
792WHA0648
793WCA0018
793WCD1732
794WHAA003
SHIELD,JACK
CABLE,CLAMP
CORD CLIP UL CO.
LAMI BAG
LIGHTRON SHEET
PACKAGE,TOP
PACKAGE,BOTTOM
GIFT,BOX BOTTOM
GIFT,BOX TOP
HANDLE
150
151
152
153
154
155
156
157
158
72784028
72784029
72784030
72784239
72784240
72784174
72781569
72784178
72784027
J3X70101A
J3X70110A
J3X70111A
J3X70199A
JA4ND500
7230008099
J3N51617A
7290000174
A3X701B975
INSTRUCTION BOOK(E)
INSTRUCTION BOOK(F)
INSTRUCTION BOOK(S)
INFORMATION SHEET
POLYBAG,INSTRUCTION(RED CAUTION)
SHEET,BARCODE
REGISTRATION CARD
SHEET,PICTURE SHIFT
INSTRUCTION BOOK KIT
201
202
203
204
205
206
207
208
209
72784033
72784031
72798791
72784034
72784214
72781255
72798789
72784215
72781977
810763080S
8117540A6S
8110630A0U
810923080S
810273060S
8109I3080U
8109I30A0U
810A140A4U
814623080U
SCREW,TAP TITE(S) BRAZIER 3*8 BK
SCREW,TAP TITE(B0) TRUSS 4*16 BK
SCREW TAP TITE(P) BRAZIER 3*10 CH
SCREW TAP TITE(B) BIND 3*8 BK
SCREW,PLANE-R M3*6 BK
SCREW TAP TITE(B) WH7 3*8 CH
SCREW TAP TITE(B) WH7 3*10 CH
SCREW WASHER(A)
M4*14 CH
SCREW TAP TITE(B) BIND 3*5.7+4*2.3 CH
210
211
212
213
214
215
216
217
218
219
72784038
72784217
72784039
72784035
72784041
72784042
72798790
72784043
72784044
72781276
810B150A0S
810B140A0U
810B150B0S
810C14080U
810F23060S
8110230A4S
811063080U
8110630A0S
8110E3080S
8117140A2U
SCREW,SEMS(B) 5*10 BK
SCREW SEMS(B) 4*10 CH
SCREW,SEMS(B) 5*20 BK
SCREW WASHER C 4*8 CH TOOTHED
SEMS(F)-R BIND 3*6 BK
SCREW TAP TITE(P) BIND 3*14 BK
SCREW TAP TITE(P) BRAZIER 3*8 CH
SCREW TAP TITE(P) BRAZIER 3*10 BK
SCREW,TAP TITE(P) WH10 3*8 BK
SCREW,TAPPING(B0) PAN 4*12 CH
K1-2
MECHANICAL REPLACEMENT PARTS LIST
Location No.
220
221
222
223
224
225
226
227
228
TSB P/N
72781277
72798795
72781295
72784036
72784218
72784032
72784040
72784219
72781292
Reference No.
8117540A0U
8117540B0U
8162540A6U
810B13080U
8167150B0U
810213080S
810233080S
830023000U
8159130A0S
Description
SCREW TAP TITE(B0) TRUSS 4*10 CH
SCREW TAP TITE(B0) TRUSS 4*20 CH
SCREW TAPPING (BO) WASHER 18
SCREW WASHER(B) M3*8 CH
SCREW WASHER(B) 5*20 CH
SCREW PAN M3*8 BK
SCREW,FLAT M3*8 BK
NUT M3
SCREW,TAPPING(B) WASHER12 PAN 3*10 BLACK
K1-3
ELECTRICAL REPLACEMENT PARTS LIST
Location No.
R3849
TSB P/N
72794621
Reference No.
Description
RESISTORS
R3X28B010J
R,METAL OXIDE
1
OHM 3W
CAPACITORS
C3801
C3802
C3803
C3823
C3825
C3826
72784045
72784045
72784045
72781395
72784046
72784046
E61FF2102D
E61FF2102D
E61FF2102D
E61FF4102D
E61FF3821D
E61FF3821D
D105
D109
D302
D303
D304
D305
D306
D802
D803
D805
D807
D808
D901
D2251
D2252
D2275
D3206
D3207
D3208
D3209
D3212
D3402
D3403
D3404
D3405
D3406
D3407
D3408
D3600
D3601
D3602
D3603
D3604
D3605
D3609
D3613
D3626
D3627
D3628
D3629
D3630
D3803
D3804
D3805
D3806
D3807
D3808
D3809
D3811
D3812
! D3900
! D3901
! D3902
D4202
D4203
D4205
D4206
D4207
D4208
D4209
D4210
D4211
D4212
D4301
D4302
72781371
72781371
72797300
72797300
72797300
72797300
72781371
72781375
72781375
72781375
72795897
72795897
72783214
72794467
72794491
72795897
72797300
72797300
72797300
72797300
72797300
72797300
72783762
72783762
72797300
72797300
72781371
72783763
72781372
72781361
72781375
72781361
72781372
72781372
72781374
72781374
72781361
72781361
72797300
72797300
72781375
72781352
72783759
72783759
72797300
72797300
72797300
72797300
72797300
72797300
72784073
72795544
72794484
72784074
72784074
72781369
72783414
72783414
72784074
72794491
72784074
72784074
72784074
72781375
72781375
DD7R20S300
DD7R20S300
D28R1QS040
D28R1QS040
D28R1QS040
D28R1QS040
DD7R20S300
DE7RB5R62B
DE7RB5R62B
DE7RB5R62B
DD7R0S3550
DD7R0S3550
D9WU05R62B
0021E9Q010
D1VT001330
DD7R0S3550
D28R1QS040
D28R1QS040
D28R1QS040
D28R1QS040
D28R1QS040
D28R1QS040
D28R11FS20
D28R11FS20
D28R1QS040
D28R1QS040
DD7R20S300
D27RX301L0
DD7R60L400
D77R1A1R10
DE7RB5R62B
D77R1A1R10
DD7R60L400
DD7R60L400
DE7RB3R32B
DE7RB3R32B
D77R1A1R10
D77R1A1R10
D28R1QS040
D28R1QS040
DE7RB5R62B
D23A0010J0
D4AT01H3E0
D4AT01H3E0
D28R1QS040
D28R1QS040
D28R1QS040
D28R1QS040
D28R1QS040
D28R1QS040
D6C047110A
D6E027110A
DOU002720M
DE7RB1202B
DE7RB1202B
D9WU06R82B
D9WU08R22B
D9WU08R22B
DE7RB1202B
D1VT001330
DE7RB1202B
DE7RB1202B
DE7RB1202B
DE7RB5R62B
DE7RB5R62B
CE
CE
CE
CE
CE
CE
1000 UF 16V
1000 UF 16V
1000 UF 16V
1000 UF 35V
820 UF 25V
820 UF 25V
DIODES
DIODE,SCHOTTKY BARRIER
DIODE,SCHOTTKY BARRIER
DIODE
DIODE
DIODE
DIODE
DIODE,SCHOTTKY BARRIER
DIODE,ZENER
DIODE,ZENER
DIODE,ZENER
DIODE,SILICON
DIODE,SILICON
DIODE,ZENER
LED
DIODE,SILICON
DIODE,SILICON
DIODE
DIODE
DIODE
DIODE
DIODE
DIODE
DIODE
DIODE
DIODE
DIODE
DIODE,SCHOTTKY BARRIER
DIODE,SCHOTTKY
DIODE,SCHOTTKY
DIODE,VARISTA
DIODE,ZENER
DIODE,VARISTA
DIODE,SCHOTTKY
DIODE,SCHOTTKY
DIODE,ZENER
DIODE,ZENER
DIODE,VARISTA
DIODE,VARISTA
DIODE
DIODE
DIODE,ZENER
DIODE,SCHOTTKY
DIODE,RECTIFIER
DIODE,RECTIFIER
DIODE
DIODE
DIODE
DIODE
DIODE
DIODE
DIODE,VARISTA
DIODE,VARISTA
DIODE,VARISTA
DIODE,ZENER
DIODE,ZENER
DIODE,ZENER
DIODE,ZENER
DIODE,ZENER
DIODE,ZENER
DIODE,SILICON
DIODE,ZENER
DIODE,ZENER
DIODE,ZENER
DIODE,ZENER
DIODE,ZENER
K2-1
RB520S-30-TE61
RB520S-30-TE61
EC31QS04-TE12L
EC31QS04-TE12L
EC31QS04-TE12L
EC31QS04-TE12L
RB520S-30-TE61
UDZS5.6B TE-17
UDZS5.6B TE-17
UDZS5.6B TE-17
1SS355 TE-17
1SS355 TE-17
MTZJ5.6B-EIC
LTL-1BEFJ-002A
1SS133T-77
1SS355 TE-17
EC31QS04-TE12L
EC31QS04-TE12L
EC31QS04-TE12L
EC31QS04-TE12L
EC31QS04-TE12L
EC31QS04-TE12L
EC11FS2-TE12L
EC11FS2-TE12L
EC31QS04-TE12L
EC31QS04-TE12L
ER RB520S-30-TE61
RSX301L-30TE25
RB160L-40-TE25
AVRL161A1R1NT
UDZS5.6B TE-17
AVRL161A1R1NT
RB160L-40-TE25
RB160L-40-TE25
UDZS3.3B TE-17
UDZS3.3B TE-17
AVRL161A1R1NT
AVRL161A1R1NT
EC31QS04-TE12L
EC31QS04-TE12L
UDZS5.6B TE-17
SBR100-10J-CBC11
1H3-E
1H3-E
EC31QS04-TE12L
EC31QS04-TE12L
EC31QS04-TE12L
EC31QS04-TE12L
EC31QS04-TE12L
EC31QS04-TE12L
ENE471D-10A
ENE271D-10A
DSS-272M-S00B
UDZS12B TE-177
UDZS12B TE-177
MTZJ6.8B-EIC
MTZJ8.2B-EIC
MTZJ8.2B-EIC
UDZS12B TE-177
1SS133T-77
UDZS12B TE-177
UDZS12B TE-177
UDZS12B TE-177
UDZS5.6B TE-17
UDZS5.6B TE-17
ELECTRICAL REPLACEMENT PARTS LIST
Location No.
TSB P/N
Reference No.
Description
ICS
IC101
IC102
IC103
IC104
IC301
IC801
IC904
IC2101
IC2275
IC2401
IC2402
IC2403
IC2404
IC2405
IC2406
IC3201
IC3202
IC3203
IC3401
IC3402
IC3403
IC3404
IC3601
IC3602
IC3605
IC3606
IC3608
IC3609
IC3611
IC3803
IC3804
IC3805
IC3808
IC4201
IC4204
IC4304
IC4305
IC4401
IC4402
IC5801
IC7202
IC7501
IC8103
IC8104
72784242
72795101
72781506
72781506
72781462
72784084
72781455
72781516
72797569
72783775
72783776
72783776
72783777
72781496
72784241
72781440
72783780
72783780
72783779
72781440
72783780
72783781
72783780
72781440
72784078
72796085
72784079
72796085
72784080
72781439
72781444
72797534
72784081
72794501
72797567
72795918
72795918
72797567
72794502
72783369
72784082
72784083
72794502
72797567
S3X701CM01
I9UF032290
ICRJ0256N0
ICRJ0256N0
I1MFPA2020
I56K07A720
I19FF4440G
IFSK0883C0
I0QF0580V0
IFNME240H0
ICLJ022ET5
ICLJ022ET5
I57F04L640
I97F052290
S3X701CF01
I07F0C0WF0
I07F078200
I07F078200
I1LF010420
I07F0C0WF0
I07F078200
I07F00HFP0
I07F078200
I07F0C0WF0
IG1F090210
I57J0L02F0
I57J0L32F0
I57J0L02F0
ICMF0T89E0
I07F093000
I0GA9XF010
I03D979950
I07A078100
I01F05853B
I0QF025840
I0QF02534V
I0QF02534V
I0QF025840
I0UF015010
I55J07W660
IF8F0385A0
IF8K010000
I0UF015010
I0QF025840
Q101
Q104
Q105
Q106
Q300
Q301
Q302
Q901
Q902
Q2101
Q2251
Q2252
Q2275
Q2276
Q2277
Q2401
Q2403
Q2404
Q2406
Q2407
Q3205
Q3206
Q3210
Q3211
Q3403
Q3404
! Q3405
Q3406
Q3407
Q3603
72794567
72783825
72798367
72783825
72794571
72794571
72794571
72794571
72794571
72794566
72784102
72794571
72794571
72795965
72794566
72783825
72783825
72783825
72783825
72783825
72798319
72795962
72794571
72794571
72794571
72794567
72783827
72794567
72798366
72783825
TNAAC05002
T2AA5132E0
TPAAC05002
T2AA5132E0
TCAA3875SY
TCAA3875SY
TCAA3875SY
TCAA3875SY
TCAA3875SY
TAAA1504SY
0001L00070
TCAA3875SY
TCAA3875SY
T67J048TL0
TAAA1504SY
T2AA5132E0
T2AA5132E0
T2AA5132E0
T2AA5132E0
T2AA5132E0
T77J011320
TNAAB05003
TCAA3875SY
TCAA3875SY
TCAA3875SY
TNAAC05002
TJYASP8K30
TNAAC05002
TPAAA05001
T2AA5132E0
!
!
!
!
!
!
!
!
!
MEMORY DATA
IC
IC
IC
IC
IC
IC
IC
IC
IC
IC
IC
IC
IC
MEMORY DATA
IC
IC
IC
IC
IC
IC
IC
IC
IC
IC
IC
IC
IC
IC
IC
IC
IC
IC
IC
IC
IC
IC
IC
IC
IC
IC
IC
IC
IC
OEC7147A
PST3229NR
AT24C256N-10SU-2.7
AT24C256N-10SU-2.7
TA2024-ASE
R8J66607A72FP
MSP4440G-QA-C13-100
MST9883C-LF-110
NJM4580V(TE1)
X240H(215H48AGA21HG)
HY5DU561622ETP-D43
HY5DU561622ETP-D43
BR24L64F-WE2
BD5229G-TR
HY27US08281A-TPCB
BA00BC0WFP-E2
BD7820FP-E2
BD7820FP-E2
AL1042
BA00BC0WFP-E2
BD7820FP-E2
BA7810HFP-TR
BD7820FP-E2
BA00BC0WFP-E2
SII9021CTU
BR24L02F-WE2
BR24L32F-WE2
BR24L02F-WE2
SST89E58RD2-40-C-TQJE
BD9300FV-E2
PQ070XF01SZH
LA7995M-TLM
BA7810T-V5
AN15853B-E1
NJM2584AM(TE1)
NJM2534V(TE2)
NJM2534V(TE2)
NJM2584AM(TE1)
MM1501XNRE
TC7W66FU(TE12L,F)
ICSV385AGLFT
DV1000-75
MM1501XNRE
NJM2584AM(TE1)
TRANSISTORS
COMPOUND TRANSISTOR
FET
COMPOUND TRANSISTOR
FET
TRANSISTOR,SILICON
TRANSISTOR,SILICON
TRANSISTOR,SILICON
TRANSISTOR,SILICON
TRANSISTOR,SILICON
TRANSISTOR,SILICON
PHOTO DIODE
TRANSISTOR,SILICON
TRANSISTOR,SILICON
TRANSISTOR,SILICON
TRANSISTOR,SILICON
FET
FET
FET
FET
FET
TRANSISTOR,SILICON
COMPOUND TRANSISTOR
TRANSISTOR,SILICON
TRANSISTOR,SILICON
TRANSISTOR,SILICON
COMPOUND TRANSISTOR
FET
COMPOUND TRANSISTOR
COMPOUND TRANSISTOR
FET
K2-2
KRC103SRTK
KTK5132E-RTK/P
KRA103SRTK
KTK5132E-RTK/P
KTC3875S_Y_RTK
KTC3875S_Y_RTK
KTC3875S_Y_RTK
KTC3875S_Y_RTK
KTC3875S_Y_RTK
KTA1504S_Y_RTK
HPI6FGR4F2
KTC3875S_Y_RTK
KTC3875S_Y_RTK
2SA2048TL
KTA1504S_Y_RTK
KTK5132E-RTK/P
KTK5132E-RTK/P
KTK5132E-RTK/P
KTK5132E-RTK/P
KTK5132E-RTK/P
2SB1132T100(Q,R)
KRC102SRTK
KTC3875S_Y_RTK
KTC3875S_Y_RTK
KTC3875S_Y_RTK
KRC103SRTK
SP8K3 TB
KRC103SRTK
KRA101SRTK
KTK5132E-RTK/P
ELECTRICAL REPLACEMENT PARTS LIST
Location No.
TSB P/N
Reference No.
Description
TRANSISTORS
Q3604
Q3605
Q3606
Q3607
Q3613
Q3614
Q3615
Q3616
Q3617
Q3618
Q3619
Q3620
Q3621
Q3801
Q3802
Q3804
Q3805
Q3806
Q3807
Q3808
Q4200
Q4201
Q4202
Q4203
Q4205
Q4206
Q4207
Q4208
Q4209
Q4210
Q4211
Q4231
Q4233
Q4302
Q4305
Q4401
Q4402
Q4403
Q4409
Q4410
Q5801
Q5802
Q5803
Q5804
Q5805
Q8101
Q8102
Q8103
Q8105
Q8106
72783825
72783825
72783825
72783825
72794571
72794571
72783825
72783825
72783825
72783825
72794571
72783825
72794571
72794572
72795962
72794572
72795962
72794571
72795964
72781787
72794566
72794566
72794571
72794571
72794571
72794571
72794571
72783825
72794571
72783825
72794566
72798367
72795962
72794571
72794571
72794566
72798367
72795962
72794566
72794566
72781807
72796429
72783390
72783390
72783390
72794566
72794571
72794571
72794566
72794566
T2AA5132E0
T2AA5132E0
T2AA5132E0
T2AA5132E0
TCAA3875SY
TCAA3875SY
T2AA5132E0
T2AA5132E0
T2AA5132E0
T2AA5132E0
TCAA3875SY
T2AA5132E0
TCAA3875SY
TPYJC05001
TNAAB05003
TPYJC05001
TNAAB05003
TCAA3875SY
T67J1036K0
T0300J6500
TAAA1504SY
TAAA1504SY
TCAA3875SY
TCAA3875SY
TCAA3875SY
TCAA3875SY
TCAA3875SY
T2AA5132E0
TCAA3875SY
T2AA5132E0
TAAA1504SY
TPAAC05002
TNAAB05003
TCAA3875SY
TCAA3875SY
TAAA1504SY
TPAAC05002
TNAAB05003
TAAA1504SY
TAAA1504SY
TPRAA05002
TNRAC05003
T82A03841Q
T82A03841Q
T82A03841Q
TAAA1504SY
TCAA3875SY
TCAA3875SY
TAAA1504SY
TAAA1504SY
L300
L301
L302
L303
L901
L903
L904
L2101
L2102
L2103
L2106
L2107
L2275
L2401
L2402
L2411
L2412
L2413
L2414
L3401
L3601
L3602
L3603
L3604
72798924
72798924
72798924
72798924
72795062
72795062
72795062
72798914
72798914
72798916
72798912
72798914
72796089
72798917
72796575
72783384
72783384
72783384
72783384
72783801
72798955
72798955
72798955
72798955
021W0G100M
021W0G100M
021W0G100M
021W0G100M
02167F100J
02167F100J
02167F100J
0216S8220K
0216S8220K
0216S8470K
0216S8150K
0216S8220K
02167F470J
0216SD1R0J
021LA62R2M
0216SDR47J
0216SDR47J
0216SDR47J
0216SDR47J
0211M44R7M
02D6000068
02D6000068
02D6000068
02D6000068
FET
FET
FET
FET
TRANSISTOR,SILICON
TRANSISTOR,SILICON
FET
FET
FET
FET
TRANSISTOR,SILICON
FET
TRANSISTOR,SILICON
COMPOUND TRANSISTOR
COMPOUND TRANSISTOR
COMPOUND TRANSISTOR
COMPOUND TRANSISTOR
TRANSISTOR,SILICON
TRANSISTOR,SILICON
FET
TRANSISTOR,SILICON
TRANSISTOR,SILICON
TRANSISTOR,SILICON
TRANSISTOR,SILICON
TRANSISTOR,SILICON
TRANSISTOR,SILICON
TRANSISTOR,SILICON
FET
TRANSISTOR,SILICON
FET
TRANSISTOR,SILICON
COMPOUND TRANSISTOR
COMPOUND TRANSISTOR
TRANSISTOR,SILICON
TRANSISTOR,SILICON
TRANSISTOR,SILICON
COMPOUND TRANSISTOR
COMPOUND TRANSISTOR
TRANSISTOR,SILICON
TRANSISTOR,SILICON
COMPOUND TRANSISTOR
COMPOUND TRANSISTOR
TRANSISTOR,SILICON
TRANSISTOR,SILICON
TRANSISTOR,SILICON
TRANSISTOR,SILICON
TRANSISTOR,SILICON
TRANSISTOR,SILICON
TRANSISTOR,SILICON
TRANSISTOR,SILICON
KTK5132E-RTK/P
KTK5132E-RTK/P
KTK5132E-RTK/P
KTK5132E-RTK/P
KTC3875S_Y_RTK
KTC3875S_Y_RTK
KTK5132E-RTK/P
KTK5132E-RTK/P
KTK5132E-RTK/P
KTK5132E-RTK/P
KTC3875S_Y_RTK
KTK5132E-RTK/P
KTC3875S_Y_RTK
DTA124EKAT146
KRC102SRTK
DTA124EKAT146
KRC102SRTK
KTC3875S_Y_RTK
2SA1036KT146
2SJ650
KTA1504S_Y_RTK
KTA1504S_Y_RTK
KTC3875S_Y_RTK
KTC3875S_Y_RTK
KTC3875S_Y_RTK
KTC3875S_Y_RTK
KTC3875S_Y_RTK
KTK5132E-RTK/P
KTC3875S_Y_RTK
KTK5132E-RTK/P
KTA1504S_Y_RTK
KRA103SRTK
KRC102SRTK
KTC3875S_Y_RTK
KTC3875S_Y_RTK
KTA1504S_Y_RTK
KRA103SRTK
KRC102SRTK
KTA1504S_Y_RTK
KTA1504S_Y_RTK
RT1P431C-T112-1
RT1N241C-T112-1
2SC3841-T1B_T63
2SC3841-T1B_T63
2SC3841-T1B_T63
KTA1504S_Y_RTK
KTC3875S_Y_RTK
KTC3875S_Y_RTK
KTA1504S_Y_RTK
KTA1504S_Y_RTK
COILS &TRANSFORMERS
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL,CHOKE
COIL,CHOKE
COIL,CHOKE
COIL,CHOKE
K2-3
10 UH
10 UH
10 UH
10 UH
10 UH
10 UH
10 UH
F 22 UH
F 22 UH
F 47 UH
F 15 UH
F 22 UH
47 UH
1 UH
2.2 UH
0.47 UH
0.47 UH
0.47 UH
0.47 UH
4.7 UH
ACM2012D-900-2P-T00
ACM2012D-900-2P-T00
ACM2012D-900-2P-T00
ACM2012D-900-2P-T00
ELECTRICAL REPLACEMENT PARTS LIST
Location No.
TSB P/N
Reference No.
Description
COILS &TRANSFORMERS
L3605
L3606
L3607
L3608
L3623
L3801
L3802
L3803
L3804
L3805
L3808
L3809
L3810
L3811
L4200
L4201
L4202
L4203
L4204
L4206
L4207
L4211
L4212
L4213
L4214
L4215
L4216
L4217
L4218
L4219
L4220
L4221
L4227
L4301
L4306
L4401
L4402
L4403
L5802
L5803
L5804
L7201
L7202
L7203
L7502
L8102
L8104
L8105
72798955
72798955
72798955
72798955
72784092
72796513
72796087
72796513
72796513
72798897
72798924
72798897
72796087
72796513
72796402
72794540
72796089
72796089
72794536
72796089
72796089
72794540
72796571
72796571
72796571
72796571
72796571
72796571
72796571
72796571
72796571
72796571
72796402
72798916
72798914
72796089
72796089
72795062
72794526
72794540
72796571
72798916
72798916
72798916
72798916
72798916
72798916
72798914
02D6000068
02D6000068
02D6000068
02D6000068
0216SD220J
02167E220K
02167E100K
02167E220K
02167E220K
0214646R8M
021W0G100M
0214646R8M
02167E100K
02167E220K
021LA6220K
02167F101J
02167F470J
02167F470J
021LA6330J
02167F470J
02167F470J
02167F101J
021LA6220J
021LA6220J
021LA6220J
021LA6220J
021LA6220J
021LA6220J
021LA6220J
021LA6220J
021LA6220J
021LA6220J
021LA6220K
0216S8470K
0216S8220K
02167F470J
02167F470J
02167F100J
02167F220J
02167F101J
021LA6220J
0216S8470K
0216S8470K
0216S8470K
0216S8470K
0216S8470K
0216S8470K
0216S8220K
J2275
J3601
J4201
J4202
J4204
J4205
J4206
J4207
J4208
J4209
J4211
J4301
72796730
72784085
72784086
72784087
72784088
72784089
72783793
72783794
72783795
72783796
72784090
72784091
060J121014
060J131019
060K411049
060K401126
060Q471008
063E000082
063E700012
060K421056
060K421058
060K421057
060Q441004
060J431025
SW2201
SW2202
SW2203
SW2204
SW2205
SW2206
72794688
72794688
72794688
72794688
72794688
72794688
0504101T34
0504101T34
0504101T34
0504101T34
0504101T34
0504101T34
PCB270
PCBD00
PCBD20
PCBD90
PCBDA0
PCBDH0
72784228
72784229
72784230
72784231
72784232
72784233
A3X701C270
A3X701CD00
A3X701CD20
A3X701CD90
A3X701CDA0
A3X701CDH0
COIL,CHOKE
COIL,CHOKE
COIL,CHOKE
COIL,CHOKE
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
COIL
ACM2012D-900-2P-T00
ACM2012D-900-2P-T00
ACM2012D-900-2P-T00
ACM2012D-900-2P-T00
22 UH
R7 22 UH
R6-1 10 UH
R7 22 UH
R7 22 UH
6.8 UH
10 UH
6.8 UH
R6-1 10 UH
R7 22 UH
22 UH
100 UH
47 UH
47 UH
33 UH
47 UH
47 UH
100 UH
22 UH
22 UH
22 UH
22 UH
22 UH
22 UH
22 UH
22 UH
22 UH
22 UH
22 UH
F 47 UH
F 22 UH
47 UH
47 UH
10 UH
22 UH
100 UH
22 UH
F 47 UH
F 47 UH
F 47 UH
F 47 UH
F 47 UH
F 47 UH
F 22 UH
JACKS
JACK,RCA,3.5
HEADPHONE JACK
RCA JACK
RCA JACK
RCA JACK
JACK PLATE
JACK
RCA JACK
RCA JACK
RCA JACK
RCA JACK
RCA JACK
MSJ-035-12A_PC
MSJ-2000B_AG(O87)
AV3-13P2-11S1
AVG-2-13
YKC21-4613N
SAV-12CP-01Z5
S4-25SZ
AV-5A-66H
AV-5A-68H
AV-5A-67H
YKC21-4720N
MSD-242VA1-03_NI_FE_LF
SWITCHES
SWITCH,TACT
SWITCH,TACT
SWITCH,TACT
SWITCH,TACT
SWITCH,TACT
SWITCH,TACT
EVQ21505R
EVQ21505R
EVQ21505R
EVQ21505R
EVQ21505R
EVQ21505R
P.C.BOARD ASSEMBLIES
OPERATION PCB ASS'Y
FILTER PCB ASS'Y
AV PCB ASS'Y
SIDE JACK PCB ASS'Y
REMOCON PCB ASS'Y
DIGITAL PCB ASS'Y
K2-4
CEE133A
CEE131A
CMF083A
CEE134A
CEF179A
CEF169A
ELECTRICAL REPLACEMENT PARTS LIST
Location No.
PCBDS0
TSB P/N
72784234
Reference No.
Description
P.C.BOARD ASSEMBLIES
A3X701CDS0
SCALER PCB ASS'Y
CEF156A
MISCELLANEOUS
B801
B802
B803
B804
B805
B806
B901
B902
B903
B904
B905
B906
B2101
B2271
B2401
B2402
B2403
B2404
B2405
B2406
B2407
B2408
B2409
B2410
B2411
B2412
B2413
B2414
B2415
B2416
B2417
B2418
B2419
B2420
B2421
B2422
B2423
B2424
B2425
B2426
B2427
B3201
B3202
B3203
B3205
B3206
B3207
B3401
B3402
B3406
B3407
B3408
B3410
B3601
B3602
B3603
B3604
B3605
B3606
B3612
B3613
B3621
B3622
B4202
B4204
B4205
B4208
B4209
B4210
B4211
B4214
B4215
B4216
72798930
72798930
72798931
72798931
72798930
72798931
72798931
72798931
72798931
72798929
72798929
72798929
72798931
72798931
72783737
72783737
72783737
72783737
72783737
72783737
72783736
72783736
72783736
72783737
72783737
72783737
72798929
72798929
72798929
72783737
72783737
72783737
72783737
72783737
72798929
72798929
72798929
72798929
72798929
72798929
72798929
72798930
72798930
72798930
72798930
72798930
72798930
72783734
72783735
72783736
72783736
72783736
72783737
72796605
72796605
72796605
72796605
72798931
72798929
72798929
72796605
72795787
72795787
72798931
72798931
72798931
72794355
72794355
72794355
72798931
72798931
72798931
72798931
024AC5181J
024AC5181J
024AC5600E
024AC5600E
024AC5181J
024AC5600E
024AC5600E
024AC5600E
024AC5600E
024AC5102F
024AC5102F
024AC5102F
024AC5600E
024AC5600E
024AC5151E
024AC5151E
024AC5151E
024AC5151E
024AC5151E
024AC5151E
024AC1601G
024AC1601G
024AC1601G
024AC5151E
024AC5151E
024AC5151E
024AC5102F
024AC5102F
024AC5102F
024AC5151E
024AC5151E
024AC5151E
024AC5151E
024AC5151E
024AC5102F
024AC5102F
024AC5102F
024AC5102F
024AC5102F
024AC5102F
024AC5102F
024AC5181J
024AC5181J
024AC5181J
024AC5181J
024AC5181J
024AC5181J
024AC5330J
024AC1391G
024AC1601G
024AC1601G
024AC1601G
024AC5151E
024HC36001
024HC36001
024HC36001
024HC36001
024AC5600E
024AC5102F
024AC5102F
024HC36001
0246C51024
0246C51024
024AC5600E
024AC5600E
024AC5600E
024HT03563
024HT03563
024HT03563
024AC5600E
024AC5600E
024AC5600E
024AC5600E
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
K2-5
BLM18PG181SN1D
BLM18PG181SN1D
BLM18BB600SN1D
BLM18BB600SN1D
BLM18PG181SN1D
BLM18BB600SN1D
BLM18BB600SN1D
BLM18BB600SN1D
BLM18BB600SN1D
BLM18BD102SN1D
BLM18BD102SN1D
BLM18BD102SN1D
BLM18BB600SN1D
BLM18BB600SN1D
BLM18BD151SN1D
BLM18BD151SN1D
BLM18BD151SN1D
BLM18BD151SN1D
BLM18BD151SN1D
BLM18BD151SN1D
BLM31PG601SN1L
BLM31PG601SN1L
BLM31PG601SN1L
BLM18BD151SN1D
BLM18BD151SN1D
BLM18BD151SN1D
BLM18BD102SN1D
BLM18BD102SN1D
BLM18BD102SN1D
BLM18BD151SN1D
BLM18BD151SN1D
BLM18BD151SN1D
BLM18BD151SN1D
BLM18BD151SN1D
BLM18BD102SN1D
BLM18BD102SN1D
BLM18BD102SN1D
BLM18BD102SN1D
BLM18BD102SN1D
BLM18BD102SN1D
BLM18BD102SN1D
BLM18PG181SN1D
BLM18PG181SN1D
BLM18PG181SN1D
BLM18PG181SN1D
BLM18PG181SN1D
BLM18PG181SN1D
BLM18PG330SN1D
BLM31PG391SN1L
BLM31PG601SN1L
BLM31PG601SN1L
BLM31PG601SN1L
BLM18BD151SN1D
HCB2012K-600T25
HCB2012K-600T25
HCB2012K-600T25
HCB2012K-600T25
BLM18BB600SN1D
BLM18BD102SN1D
BLM18BD102SN1D
HCB2012K-600T25
MMZ1608R102CT
MMZ1608R102CT
BLM18BB600SN1D
BLM18BB600SN1D
BLM18BB600SN1D
W4BRH3.5X6X1.0X2
W4BRH3.5X6X1.0X2
W4BRH3.5X6X1.0X2
BLM18BB600SN1D
BLM18BB600SN1D
BLM18BB600SN1D
BLM18BB600SN1D
ELECTRICAL REPLACEMENT PARTS LIST
Location No.
B4217
B4218
B4219
B4220
B4221
B4222
B4225
B4303
B4304
B4305
B4307
B4308
B4461
B5801
B5802
B5803
B5805
B7202
B7501
B7502
BT001
BT002
CD301
CD303
CD801
CD802
CD901
CP101
CP102
CP103
CP301
CP303
CP802
CP803
CP901
CD2203
CD3801
CD3802
CD3803
CD3804
CD3807
! CD3820
CD3831
CD3900
CD3901
CD4200
CD4202
CD4203
CD4204
CD7206
CP2200
CP2203
CP2251
CP2403
CP2404
CP2405
CP3201
CP3601
CP3602
CP3603
CP3604
CP3801
CP3802
CP3803
CP3804
CP3807
! CP3900
! CP3901
CP4200
CP4201
CP4202
CP4203
CP4204
CP4302
CP5801
TSB P/N
72798931
72798931
72798931
72798931
72798931
72798931
72798931
72798931
72798931
72798931
72795787
72795787
72795787
72798930
72798930
72798930
72798930
72798931
72798931
72798930
72783174
72783174
72784048
72784159
72784062
72784062
72784063
72796798
72796806
72796801
72784066
72796792
72799028
72799027
72796796
72784047
72784160
72784051
72784161
72784053
72784054
72784055
72784056
72784057
72784058
72784059
72784060
72799271
72799273
72784061
72796794
72796795
72799047
72784064
72784064
72784065
72796807
72799030
72796796
72799030
72796804
72784067
72784068
72784069
72784070
72796807
72796817
72796817
72796803
72796803
72796800
72799027
72799028
72799010
72784071
Reference No.
Description
MISCELLANEOUS
024AC5600E
024AC5600E
024AC5600E
024AC5600E
024AC5600E
024AC5600E
024AC5600E
024AC5600E
024AC5600E
024AC5600E
0246C51024
0246C51024
0246C51024
024AC5181J
024AC5181J
024AC5181J
024AC5181J
024AC5600E
024AC5600E
024AC5181J
141U004016
141U004016
06CU13A301
06CU12A501
06CH011208
06CH011208
06CU247001
069S250629
069S2A0629
069S270629
069S130419
069S120419
069EVU3030
069EVT3030
069S240629
06CU23A001
06CU641802
06CU622201
06CU6C1701
06CU672301
06CU2B3901
120D024502
06CU012202
06CUU21001
06CUU33002
06CU28A005
06CU267901
122H0T0801
122H0U0802
06CUZV6301
069S230629
069S230639
069S260639
06972KT059
06972KT059
069AAA1009
069S2B0629
069HYJ3010
069S240629
069HYJ3010
069S290629
069S140019
069S120019
069S1C0019
069S170019
069S2B0629
069S320419
069S320419
069S280629
069S280629
069S260629
069EVT3030
069EVU3030
0694S15017
06972KM020
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
CORE,BEADS
BATTERY,MANGAN
BATTERY,MANGAN
CORD,CONNECTOR
CORD,CONNECTOR
CORD,CONNECTOR
CORD,CONNECTOR
CORD,CONNECTOR
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
CORD,CONNECTOR
CORD,CONNECTOR
CORD,CONNECTOR
CORD,CONNECTOR
CORD,CONNECTOR
CORD,CONNECTOR
CORD AC
CORD,CONNECTOR
CORD,CONNECTOR
CORD,CONNECTOR
CORD,CONNECTOR
CORD,CONNECTOR
CORD,JUMPER
CORD,JUMPER
CORD,CONNECTOR
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
K2-6
BLM18BB600SN1D
BLM18BB600SN1D
BLM18BB600SN1D
BLM18BB600SN1D
BLM18BB600SN1D
BLM18BB600SN1D
BLM18BB600SN1D
BLM18BB600SN1D
BLM18BB600SN1D
BLM18BB600SN1D
MMZ1608R102CT
MMZ1608R102CT
MMZ1608R102CT
BLM18PG181SN1D
BLM18PG181SN1D
BLM18PG181SN1D
BLM18PG181SN1D
BLM18BB600SN1D
BLM18BB600SN1D
BLM18PG181SN1D
MNAAA(R03)
MNAAA(R03)
CU13A301
CU12A501
CH011208
CH011208
CU247001
A2001WV2-5P
A2001WV2-10P
A2001WV2-7P
A2502WV2-3P
A2502WV2-2P
00_6232_030_006_800+
00_6232_029_006_800+
A2001WV2-4P
CU23A001
CU641802
CU622201
CU6C1701
CU672301
CU2B3901
4L0J-050-00K
CU012202
CUU21001
CUU33002
CU28A005
CU267901
2H0T0801
2H0U0802
CUZV6301
A2001WV2-3P
A2001WR2-3P
A2001WR2-6P
125607220W3
125607220W3
YKF45-0036N
A2001WV2-11P
DC1R019JDA
A2001WV2-4P
DC1R019JDA
A2001WV2-9P
A2501WV2-4P
A2501WV2-2P
A2501WV2-12P
A2501WV2-7P
A2001WV2-11P
A3963WV2-3PD
A3963WV2-3PD
A2001WV2-8P
A2001WV2-8P
A2001WV2-6P
00_6232_029_006_800+
00_6232_030_006_800+
1-1734344-1
TKC-W20P-U1
ELECTRICAL REPLACEMENT PARTS LIST
Location No.
!
!
!
!
!
!
!
CP5802
CP7202
ELD001
ELD002
F3900
FH3900
FH3901
NR801
NR802
NR803
NR804
NR805
NR806
NR807
NR2101
NR2102
NR2103
NR2104
NR2105
NR2106
NR2401
NR2402
NR2403
NR2404
NR2405
NR2406
NR2407
NR2408
NR2409
NR2410
NR2411
NR2412
NR2413
NR3601
NR3602
NR3603
NR3604
NR3605
NR3606
NR7203
NR7204
NR7501
NR7502
NR7503
NR7504
NR7505
NR7506
OS2251
OS4202
PH3900
PH3901
SP301
SP302
SP303
SP304
TM101
TR301
TR302
TR3805
TR3806
TR3820
TR4201
TR4202
TR4205
TR4206
TR6501
TR6502
TU5801
V801
V802
X101
X801
X901
X2401
X2402
TSB P/N
72784071
72784072
72797069
72797070
72784075
72794496
72794496
72799237
72799240
72799240
72799240
72799240
72799240
72799240
72797034
72797034
72797034
72797034
72797034
72797034
72783802
72783385
72783385
72783385
72783385
72783803
72783803
72783803
72783803
72783803
72783803
72783803
72783803
72799237
72799237
72799237
72799237
72799237
72799237
72799238
72799238
72799240
72799240
72799240
72799240
72799240
72799240
72784093
72784094
72796825
72796825
72784103
72784103
72784104
72784104
72781948
72796088
72796088
72784107
72784106
72784105
72796088
72796088
72784107
72784106
72784107
72796088
72783832
72784162
72784163
72799226
72799227
72797001
72783833
72783834
Reference No.
Description
MISCELLANEOUS
06972KM020
069HTR001A
124116281A
124120301A
081PC08005
06710T0009
06710T0009
110P4000M4
110P4470M4
110P4470M4
110P4470M4
110P4470M4
110P4470M4
110P4470M4
110P4101M4
110P4101M4
110P4101M4
110P4101M4
110P4101M4
110P4101M4
110P4102M5
110P4220M6
110P4220M6
110P4220M6
110P4220M6
110P4560M5
110P4560M5
110P4560M5
110P4560M5
110P4560M5
110P4560M5
110P4560M5
110P4560M5
110P4000M4
110P4000M4
110P4000M4
110P4000M4
110P4000M4
110P4000M4
110P4220M4
110P4220M4
110P4470M4
110P4470M4
110P4470M4
110P4470M4
110P4470M4
110P4470M4
077A033001
07AE000012
069W01001A
069W01001A
0701016002
0701016002
0701026001
0701026001
076D0KK020
02AHB9A972
02AHB9A972
02A6C0A3Y1
02A6B3A3T1
02A6A990S2
02AHB9A972
02AHB9A972
02A6C0A3Y1
02A6B3A3T1
02A6C0A3Y1
02AHB9A972
0164100007
09HD142004
09JE042002
100WT01611
100YT05401
100CT01803
100DT05501
100DT02503
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
EYE LET
EYE LET
FUSE
HOLDER,FUSE
HOLDER,FUSE
R,NETWORK
R,NETWORK
R,NETWORK
R,NETWORK
R,NETWORK
R,NETWORK
R,NETWORK
R,NETWORK
R,NETWORK
R,NETWORK
R,NETWORK
R,NETWORK
R,NETWORK
R,NETWORK
R,NETWORK
R,NETWORK
R,NETWORK
R,NETWORK
R,NETWORK
R,NETWORK
R,NETWORK
R,NETWORK
R,NETWORK
R,NETWORK
R,NETWORK
R,NETWORK
R,NETWORK
R,NETWORK
R,NETWORK
R,NETWORK
R,NETWORK
R,NETWORK
R,NETWORK
R,NETWORK
R,NETWORK
R,NETWORK
R,NETWORK
R,NETWORK
R,NETWORK
R,NETWORK
REMOTE RECEIVER
OPTICAL DEVICE
CONNECTOR PCB SIDE
CONNECTOR PCB SIDE
SPEAKER
SPEAKER
SPEAKER
SPEAKER
TRANSMITTER
CORE,FERRITE
CORE,FERRITE
CORE,FERRITE
CORE,FERRITE
CORE,FERRITE
CORE,FERRITE
CORE,FERRITE
CORE,FERRITE
CORE,FERRITE
CORE,FERRITE
CORE,FERRITE
DIGITAL TUNER
PDP
PDP FILTER
CRYSTAL
CRYSTAL
CRYSTAL
CRYSTAL
CRYSTAL
K2-7
TKC-W20P-U1
FI-TWE31PB-VF
XRY16X28BD
XRY20X30BD
51MS080L
EYF-52BCY
EYF-52BCY
4D03WGJ0000T5E
4D03WGJ0470T5E
4D03WGJ0470T5E
4D03WGJ0470T5E
4D03WGJ0470T5E
4D03WGJ0470T5E
4D03WGJ0470T5E
4D03WGJ0101T5E
4D03WGJ0101T5E
4D03WGJ0101T5E
4D03WGJ0101T5E
4D03WGJ0101T5E
4D03WGJ0101T5E
4D02WGJ0102TCE
4D02WGJ0220TCE
4D02WGJ0220TCE
4D02WGJ0220TCE
4D02WGJ0220TCE
4D02WGJ0560TCE
4D02WGJ0560TCE
4D02WGJ0560TCE
4D02WGJ0560TCE
4D02WGJ0560TCE
4D02WGJ0560TCE
4D02WGJ0560TCE
4D02WGJ0560TCE
4D03WGJ0000T5E
4D03WGJ0000T5E
4D03WGJ0000T5E
4D03WGJ0000T5E
4D03WGJ0000T5E
4D03WGJ0000T5E
4D03WGJ0220T5E
4D03WGJ0220T5E
4D03WGJ0470T5E
4D03WGJ0470T5E
4D03WGJ0470T5E
4D03WGJ0470T5E
4D03WGJ0470T5E
4D03WGJ0470T5E
ROM-V338TAO
TOTX177(F,T)
003P-2100
003P-2100
EAS12D175B
EAS12D175B
EAS5PH134C
EAS5PH134C
ORT204UA605025-J
W5T29X7.5X19
W5T29X7.5X19
ZCAT3035-1330
ZCAT2436-1330A
ZCAT2035-0930A-BK
W5T29X7.5X19
W5T29X7.5X19
ZCAT3035-1330
ZCAT2436-1330A
ZCAT3035-1330
W5T29X7.5X19
ENG36A53KF
PDP42X3####
FG410NAA-05
HC-49/U-S
FCX-03
HC-49/U-S
SMD-49
SMD-49
ELECTRICAL REPLACEMENT PARTS LIST
Location No.
X3601
X3602
X7501
TSB P/N
72799220
72783835
72784110
Reference No.
Description
MISCELLANEOUS
100CT01101
100DT02801
100DT02006
CRYSTAL
CRYSTAL
CRYSTAL
RESISTOR
RC................... CARBON RESISTOR
CAPACITORS
CC................... CERAMIC CAPACITOR
CE................... ALUMI ELECTROLYTIC CAPACITOR
CP................... POLYESTER CAPACITOR
CPP................. POLYPROPYLENE CAPACITOR
CPL................. PLASTIC CAPACITOR
CMP................ METAL POLYESTER CAPACITOR
CMPL.............. METAL PLASTIC CAPACITOR
CMPP.............. METAL POLYPROPYLENE CAPACITOR
K2-8
HC-49/U-S
SMD-49
DSO751SV
TOSHIBA CORPORATION
1-1, SHIBAURA 1-CHOME, MINATO-KU, TOKYO 105-8001, JAPAN