Download Sansui HDLCD1909 Service manual
Transcript
SERVICE MANUAL 19" WIDE TFT LCD TELEVISION WITH DIGITAL TUNER HDLCD1909 All the specifications and features are subject to change without notice. ORIGINAL VERSION (B) S/M CODE NO. M39A05WASM DATE OF ISSUE 8/2009 IMPORTANT SERVICE SAFETY INFORMATION Operating the receiver outside of its cabinet or with its back removed involves a shock hazard. Work on these models should only be performed by those who are thoroughly familiar with precautions necessary when working on high voltage equipment. Before returning the receiver to the user, perform the following safety checks: 1. Inspect all lead dress to make certain that leads are not pinched or that hardware is not lodged between the chassis and other metal parts in the receiver. 2. Replace all protective devices such as nonmetallic control knobs, insulating fishpapers, cabinet backs, adjustment and compartment covers or shields, isolation resistor-capacitor networks, mechanical insulators, etc. 3. To be sure that no shock hazard exists, a check for the presence of leakage current should be made at each exposed metal part having a return path to the chassis (antenna, cabinet metal, screw heads, knobs and/or shafts, escutcheon, etc.) in the following manner. Exercise care when servicing this chassis with power applied. Many B plus and high voltage RF terminals are exposed which, if carelessly contacted, can cause serious shock or result in damage to the chassis. Maintain interconnecting ground lead connections between chassis, escutcheon, picture tube dag and tuner cluster when operating the chassis. These receivers have a "polarized" AC line cord. The AC plug is designed to fit into standard AC outlets in one direction only. The wide blade connects to the "ground side" and the narrow blade connects to the "hot side" of the AC line. This assures that the TV receiver is properly grounded to the house wiring. If an extension cord must be used, make sure it is of the "polarized" type. Plug the AC line cord directly into a 120V AC receptacle. (Do not use an Isolation Transformer during these checks.) All checks must be repeated with the AC line cord plug connection reversed. (If necessary, a nonpolarized adapter plug must be used only for the purpose of completing these checks.) Since the chassis of this receiver is connected to one side of the AC supply during operation, service should not be attempted by anyone not familiar with the precautions necessary when working on these types of equipment. If available, measure current using an accurate leakage current tester. Any reading of 0.35mA or more is excessive and indicates a potential shock hazard which must be corrected before returning the receiver to the owner. When it is necessary to make measurements or tests with AC power applied to the receiver chassis, an Isolation Transformer must be used as a safety precaution and to prevent possible damage to transistors. The Isolation Transformer should be connected between the TV line cord plug and the AC power outlet. If a reliable leakage current tester is not available, this alternate method of measurement should be used. Using two clip leads, connect a 1500 ohm, 10 watt resistor paralleled by a 0.15µF capacitor in series with a known earth ground, such as a water pipe or conduit and the metal part to be checked. Use a VTVM or VOM with 1000 ohms per volt, or higher, sensitivity to measure this AC voltage drop across the resistor. Any reading of 0.35 volt RMS or more is excessive and indicates a potential shock hazard which must be corrected before returning the receiver to the owner. When removing springs or spring mounted parts from the tuner, tuner cluster or chassis, shatterproof goggles must be worn. Keep others without shatterproof goggles away. VT VM AC SCALE 0.15K OHMS 10W TO EXPOSED METAL PARTS A1-1 10µF TEST PROBE TO KNOWN EARTH GROUND ABOUT LEAD FREE SOLDER (PbF) Distinction of PbF PCB: PCBs (manufactured) using lead free solder will have a PbF printing on the PCB. (Please refer to figures.) Caution: • Pb free solder has a higher melting point than standard solder; Typically the melting point is 86oF~104oF(30oC~40oC) higher. Please use a soldering iron with temperature control and adjust it to 650oF ± 20oF (350oC ± 10oC). In case of using high temperature soldering iron, please be careful not to heat too long. • Pb free solder will tend to splash when heated too high (about 1100oF/ 600oC). • All products with the printed circuit board with PbF printing must be serviced with lead free solder. When soldering or unsoldering, completely remove all of the solder from the pins or solder area, and be sure to heat the soldering points with the lead free solder until it melts sufficiently. Recommendations Recommended lead free solder composition is Sn-3.0Ag-0.5Cu. A1-2 TABLE OF CONTENTS IMPORTANT.................................................................................................................................... A1-1 ABOUT LEAD FREE SOLDER (PbF)............................................................................................. A1-2 TABLE OF CONTENTS................................................................................................................... A2-1 GENERAL SPECIFICATIONS......................................................................................................... A3-1~A3-5 DISASSEMBLY INSTRUCTIONS 1. REMOVAL OF MECHANICAL PARTS AND P. C. BOARDS................................................. B1-1, B1-2 2. REMOVAL AND INSTALLATION OF FLAT PACKAGE IC.....................................................B2-1, B2-2 SERVICE MODE LIST..................................................................................................................... C-1 WHEN REPLACING EEPROM (MEMORY) IC................................................................................ C-2 CONFIRMATION OF INITIAL DATA............................................................................................... C-2 ELECTRICAL ADJUSTMENTS....................................................................................................... D-1~D-6 TROUBLESHOOTING GUIDE......................................................................................................... E-1~E-4 IC DESCRIPTION............................................................................................................................ F-1~F-6 SEMICONDUCTOR BASE CONNECTIONS................................................................................... G-1 BLOCK DIAGRAMS POWER/SOUND AMP ............................................................................................................... H-1, H-2 SIGNAL (DIGITAL PCB).............................................................................................................. H-3, H-4 POWER(DIGITAL PCB).............................................................................................................. H-5, H-6 PRINTED CIRCUIT BOARDS DIGITAL ...................................................................................................................................... I-1~I-4 POWER/OPERATION/REMOCON............................................................................................. I-5~I-8 SCHEMATIC DIAGRAMS FLASH......................................................................................................................................... J-1, J-2 DDR............................................................................................................................................. J-3, J-4 HDMI............................................................................................................................................ J-5, J-6 LVDS........................................................................................................................................... J-7, J-8 SCALER...................................................................................................................................... J-9, J-10 SCALER POWER........................................................................................................................ J-11, J-12 TUNER........................................................................................................................................ J-13, J-14 SCALER VIDEO/AUDIO ............................................................................................................. J-15, J-16 JACK............................................................................................................................................ J-17, J-18 AV SWITCH................................................................................................................................. J-19, J-20 REGULATOR.............................................................................................................................. J-21, J-22 POWER....................................................................................................................................... J-23, J-24 BACKLIGHT INVERTER............................................................................................................. J-25, J-26 SOUND AMP............................................................................................................................... J-27, J-28 JACK OUT................................................................................................................................... J-29, J-30 INTERCONNECTION DIAGRAM..................................................................................................... J-31, J-32 WAVEFORMS.................................................................................................................................. K-1 MECHANICAL EXPLODED VIEWS................................................................................................ L-1, L-2 MECHANICAL REPLACEMENT PARTS LIST............................................................................... M1-1 ACCESSORY REPLACEMENT PARTS LIST................................................................................. M1-1 ELECTRICAL REPLACEMENT PARTS LIST................................................................................ M2-1~M2-5 A2-1 GENERAL SPECIFICATIONS G-1 TV System LCD LCD Size / Visual Size LCD Type Number of Pixels View Range Left/Right Up/Down Bright Dot Zero Bright Dot Ratio Color System Speaker Sound Output G-2 Tuning System Broadcasting System Tuner and Receive CH CH Coverage Intermediate Digital Frequency Analog G-3 Signal Power Picture(FP) Sound(FS) FP-FS Preset CH Stereo/Dual TV Sound Tuner Sound Muting Video Signal Input Level Output Level S/N Ratio (Weighted) Horizontal Resolution at DVD Mode RGB Signal Audio Signal G-4 Position Size Impedance Max 10%(Typical) Analog Digital System Destination Power Source Power Consumption Protector Output Level Input Level Output Level Digital Output Level S/N Ratio at DVD (Weighted) Harmonic Distortion Frequency Response : at DVD at Video CD at SVCD at CD AC DC at AC at DC Stand by (at AC) Energy Star Per Year Power Fuse Safety Circuit IC Protector(Micro Fuse) Safety Radiation Laser Operation Storage Space Around Unit G-5 Regulation G-6 Temperature G-7 G-8 Operating Humidity Clock and Clock Timer Sleep Timer Max Time On Timer Program Off Timer Program Game Timer Wake Up Timer Timer Back-up (at Power Off Mode) Remote Unit Control Glow in Dark Remocon Remocon Format Format Custom Code Power Source Voltage(D.C) UM size x pcs Total Keys Keys Power 1 2 G-9 at DVD at TV more than A3-1 18.50 inch / 470.1mmV Color TFT LCD 1366(H) x 768(V) 85/85 degree 80/80 degree < n=3 70% NTSC 2 Speaker Front 1.0 x 2.7 inch 8 ohm 1.0W + 1.0W --US System M ATSC(8VSB)/QAM 1Tuner US (W/CABLE) 2~69, 4A, A-5~A-1, A~I, J~W, W+1~W+94 44.00MHz 45.75MHz 41.25MHz 4.50MHz No US-Stereo Yes 1 V p-p/75 ohm ------8.0dBm/50k ohm ---0.5 V p-p/75 ohm ------120V, 60Hz -29W at 120V 60Hz -0.8W at 120V 60Hz Yes -- kWh/Year Yes Yes Yes UL(UL60065_7th) FCC -o o +5 C ~ +40 C o o -20 C ~ +60 C 10cm (4inch) Less than 80% RH No 120 Min No No No No -Min Sec RC-RC No ORION NEC 86-05 h 3V UM-4 x 2 pcs 27 Keys Yes Yes Yes GENERAL SPECIFICATIONS 3 4 5 6 7 8 9 0 Recall (Quick View) Sleep Mute CH+ / Up CH- / Down VOL+ / Right VOL- / Left Menu Reset Exit Enter Input Select CCD (Closed Caption) Display Zoom (Picture Size) FAV + FAV Audio G-10 Features Yes Yes Yes Yes Yes Yes Yes Yes Yes Yes Yes Yes Yes Yes Yes Yes Yes No Yes Yes Yes Yes Yes Yes No No Yes Yes Auto Shut Off Auto Search Power On Memory Comb Filter No Yes Yes 3 -D Game Position Auto Setup(Language/CH Program) Picture Setting(TV) Picture Preference Brightness , Contrast , Color Tint Sharpness Color Temperature DNR Backlight Picture Setting(PC) HOR Position , VER Position Phase, Clock Red, Green, Blue Auto Adjust Audio MTS Tone Control (Bass/Treble/Balance) Stable Sound Surround BBE SRS WOW (SRS 3D/Focus/Tru Bass) Variable Audio Out Tuning CH Program Air/Cable ADD/DELETE Label CH Label Video Label Favorite CH V-Chip Type RRT Setup Lock Hotel Lock Channel Lock Video Lock Panel Lock Menu Language DBC (Dynamic Backlight Control) Signal Meter (DTV Signal) Closed Caption CC Advanced V-Chip Clear Picture Size HD Zoom Film Mode Aspect PFC(Power Factor circuit) A3-2 No Yes Yes Yes Yes Yes Yes Yes Yes Yes Yes Yes Yes No Yes Yes Yes No Yes No No No Yes Yes Yes Yes Yes No Yes USA Type Yes No No No No English No Yes Yes Yes Yes Yes Yes Yes No No GENERAL SPECIFICATIONS Freeze frame PIP/POP Direct Input Selection Digital Out No No Yes Yes Dolby Digital MPEG PCM DTS No Yes No Yes Yes (60,72,75Hz) Yes (70Hz) No Yes (56,60,72,75Hz) Yes (60,70,75Hz) Yes (60Hz) Yes (60Hz) Yes (60Hz) No No No No No No No No No No No No No No No No No No No No No No No No No No Yes Yes (60Hz) Yes (60Hz) Yes (60Hz) Yes (60Hz) No No No No Yes (60Hz) Yes (60Hz) No Yes (100 x 100) M4 x 10 No No English Yes Yes No --No -No No No No No No No No No No Yes UM-4 x 2 pcs PC Monitor Input VGA (640x480) VGA (720x400) WVGA (848x480) SVGA (800x600) XGA (1024x768) WXGA (1280x768) WXGA (1280x720) WXGA (1360x768) SXGA (1280x1024) HDMI Input DVI to HDMI Input VGA (640×480) 720×480i (4:3) 720×480i (16:9) 720×480p (4:3) 720×480p (16:9) 720×576i (4:3) 720×576i (16:9) 720×576p (4:3) 720×576p (16:9) 1280×720p 1920×1080i 1920×1080p CEC (ORION Standard) Deep Color xvYCC VGA (640x480) VGA (720x400) WVGA (848x480) SVGA (800x600) XGA (1024x768) WXGA (1280x768) WXGA (1280x720) WXGA (1360x768) SXGA (1280x1024) Component Input Wall Mount Stand G-11 Accessories Owner's Manual 720×480i (4:3) 720×480i (16:9) 720×480p (4:3) 720×480p (16:9) 720×576i (4:3) 720×576i (16:9) 720×576p (4:3) 720×576p (16:9) 1280×720p 1920×1080i 1920×1080p Size W x H(mm) Screw Size Tilt Swievel Language w/Guarantee Card Remote Control Unit Rod Antenna Poles Terminal Loop Antenna Terminal U/V Mixer DC Car Cord (Center+) Guarantee Card Warning Sheet Circuit Diagram Antenna Change Plug Service Facility List Important Safeguard Dew/AHC Caution Sheet Quick Set-up Sheet Battery UM size x pcs A3-3 GENERAL SPECIFICATIONS G-12 Interface G-13 Set Size G-14 Weight G-15 Carton OEM Brand AC Adapter AC Cord (for AC Adapter) AC Cord AV Cord (2Pin-1Pin) Registration Card (NDL Card) 300 to 75ohm Antenna Adapter Sheet Information (FCC) Sheet Information (Return) Sheet Information (HDMI) Stand Stand Screw??? Switch Side Power (Tact) Channel Up/Menu Up Channel Down/Menu Down Volume Up/Menu > Volume Down/Menu < Menu Play Eject Skip+, Search+ Skip-, SearchStill/Pause Stop Main Power SW Input Select/Enter Rear Main Power SW Indicator Stand-By Power Wake Up On Timer Terminals Rear Video Input 1 Audio Input 1 S - Input 1 Video Input 2 Audio Input 2 S - Input 2 Video Output Audio Output Component Input 1 Analog Audio Component Input 2 Analog Audio HDMI Input 1 Analog Audio HDMI Input 2 Analog Audio Sub Woofer Out PC Monitor Input Analog Audio Digital Audio Output DC Jack (Center +) VHF/UHF Antenna Input Video Input 3 Audio Input 3 S - Input 3 Other Terminal AC Inlet Approx. W x D x H (mm) w/o Handle, Stand Approx. W x D x H (mm) Net (Approx.) Net w/o Handle, Stand (Approx.) Gross (Approx.) Gross w/Master Carton (Approx.) Master Carton Content Material Dimensions W x D x H(mm) Description of Origin Gift Box Material W/Color Photo Label W/Handle Dimensions W x D x H(mm) Description of Origin Drop Test Height (cm) Container Stuffing (40' container) w/Pallet w/Wrapping A3-4 No No No Yes No No No No Yes No Yes Yes (2pcs) Yes Yes Yes Yes Yes Yes No No No No No No No Yes No Yes (Red) No No RCA x 1 RCA x 2(L/MONO, R) Yes No No No No No RCA x 3 RCA x 2(L/MONO, R) No No No No No No No Yes Mini Pin Jack( 3.5), STEREO Coaxial No F Type No No No No Yes 472 x 174 x 362 472 x 64 x 328 3.8kg (8.4lbs) 3.5kg (7.7lbs) 5.0kg (11.1lbs) --- kg ( --- lbs) No --- Sets --- / ------Single/White No No 542 x 426 x 147 Yes 1 Corner / 3 Edges / 6 Surfaces 80 1852 Sets/40' container No No GENERAL SPECIFICATIONS G-16 Material G-17 Environment Cabinet Front Rear Jack Panel PCB Non-Halogen Demand Eyelet Demand Environmental standard requirement Pb-free Measures for Whisker A3-5 PS 94V0 NON-DECABROM PS 94V0 NON-DECABROM -No Yes Green procurement of ORION Phase3(Phase3A) Yes DISASSEMBLY INSTRUCTIONS 1. REMOVAL OF MECHANICAL PARTS AND P.C. BOARDS 1-3: FRONT CABI ASS'Y and LCD PANEL (Refer to Fig. 1-3) 1. Turn up set and put the Front Cabi Ass'y of LCD on the top. 2. Remove the Front Cabi Ass'y in the direction of arrow (A). 3. Disconnect the following connector: (CD2801). 4. Remove the LCD Panel in the direction of arrow (B). CAUTION Be careful not to remove the LVDS cable forcibly, because the LVDS cable may be damaged. 1-1: STAND ASS'Y (Refer to Fig. 1-1) 1. Remove the 2 screws (1). 2. Remove the Stand Ass'y in the direction of arrow. (1) (1) (A) Front Cabi Ass'y Stand Ass'y Fig. 1-1 11 1-2: COVER INVERTER (Refer to Fig. 1-2) 1. Remove the screw (1). 2. Remove the Cover Inverter in the direction of arrow. 3. Disconnect the following connectors: (CP7001 and CP7002). 4. Remove the 2 screws (2) 5. Remove the 6 screws (3) CD2801 (LVDS Cable) (1) Cover Inverter (3) (2) (3) (2) (3) (3) (3) LCD Panel (3) (B) Fig. 1-2 Back Cabi Ass'y Fig. 1-3 B1-1 DISASSEMBLY INSTRUCTIONS 1-4: DIGITAL PCB (Refer to Fig. 1-5) 1-5: POWER PCB, REMOCON PCB and OPERATION PCB (Refer to Fig. 1-5) 1. 2. 3. 4. 5. 6. Remove the 2 screws (1). Remove the Holder LCD in the direction of arrow (A). Remove the 2 screws (2). Remove the Holder LVDS-3 in the direction of arrow (B). Remove the 2 screws (3). Disconnect the following connectors: (CP501, CP2201 and CP8101). 7. Remove the Digital PCB in the direction of arrow (C). 1. 2. 3. 4. 5. 6. 7. 8. 9. (1) Disconnect the following connector: (CP7601). Remove the 7 screws (1). Remove the Power PCB in the direction of arrow (A). Remove the screw (2). Remove the Remocon PCB in the direction of arrow (B). Push 9 supports (3). Remove the Panel Side Ass'y in the direction of arrow (C). Remove the 2 screws (4). Remove the Operation PCB in the direction of arrow (D). (1) Holder LCD (1) (2) (2) (1) (1) (1) Holder LVDS-3 (3) (B) Digital PCB (1) (1) (A) (1) (3) (2) Remocon PCB Power PCB (C) (A) (B) C Ass'y Back Cabi Fig. 1-4 Back Cabi Ass'y (C) (4) (4) Operation PCB (D) Panel Side Ass'y (3) (3) Fig. 1-5 B1-2 DISASSEMBLY INSTRUCTIONS 2. REMOVAL AND INSTALLATION OF FLAT PACKAGE IC 3. When IC starts moving back and forth easily after desoldering completely, pickup the corner of the IC using tweezers and remove the IC by moving with the IC desoldering machine. (Refer to Fig. 2-3.) REMOVAL 1. Put Masking Tape (cotton tape) around the Flat Package IC to protect other parts from any damage. (Refer to Fig. 2-1.) NOTE Some ICs on the PCB are affixed with glue, so be careful not to break or damage the foil of each IC leads or solder lands under the IC when removing it. NOTE Masking is carried out on all the parts located within 10 mm distance from IC leads. Masking Tape (Cotton Tape) Blower type IC desoldering machine IC Tweezers Fig. 2-1 2. Heat the IC leads using a blower type IC desoldering machine. (Refer to Fig. 2-2.) IC Fig. 2-3 NOTE Do not rotate or move the IC back and forth , until IC can move back and forth easily after desoldering the leads completely. 4. Peel off the Masking Tape. 5. Absorb the solder left on the pattern using the Braided Shield Wire. (Refer to Fig. 2-4.) Blower type IC desoldering machine NOTE Do not move the Braided Shield Wire in the vertical direction towards the IC pattern. Braided Shield Wire Soldering Iron IC Fig. 2-2 IC pattern Fig. 2-4 B2-1 DISASSEMBLY INSTRUCTIONS INSTALLATION 4. When bridge-soldering between terminals and/or the soldering amount are not enough, resolder using a Thintip Soldering Iron. (Refer to Fig. 2-8.) 1. Take care of the polarity of new IC and then install the new IC fitting on the printed circuit pattern. Then solder each lead on the diagonal positions of IC temporarily. (Refer to Fig. 2-5.) Thin-tip Soldering Iron IC Soldering Iron Fig. 2-8 Solder temporarily 5. Finally, confirm the soldering status on four sides of the IC using a magnifying glass. Confirm that no abnormality is found on the soldering position and installation position of the parts around the IC. If some abnormality is found, correct by resoldering. Solder temporarily Fig. 2-5 NOTE 2. Supply the solder from the upper position of IC leads sliding to the lower position of the IC leads. (Refer to Fig. 2-6.) When the IC leads are bent during soldering and/or repairing, do not repair the bending of leads. If the bending of leads are repaired, the pattern may be damaged. So, always be sure to replace the IC in this case. Solder Soldering Iron IC Supply soldering from upper position to lower position Fig. 2-6 3. Absorb the solder left on the lead using the Braided Shield Wire. (Refer to Fig. 2-7.) NOTE Do not absorb the solder to excess. Soldering Iron IC Braided Shield Wire Fig. 2-7 B2-2 SERVICE MODE LIST This unit is provided with the following SERVICE MODES so you can repair, examine and adjust easily. To enter to the SERVICE MODE function, press and hold both buttons simultaneously on the main unit and on the remote control for more than a the standard time in the appropriate condition. (See below chart.) Set Condition Set Key Remocon Key Standard Time POWER ON VOL. DOWN (Minimum) 0 2 sec. Releasing of V-CHIP PASSWORD. POWER ON VOL. DOWN (Minimum) 1 2 sec. Initialization of factory TV data. NOTE: If you set factory initialization, the memories are reset such as the channel setting, and the POWER ON total hours. POWER ON VOL. DOWN (Minimum) 6 2 sec. Can be checked of the INITIAL DATA of MEMORY IC. Refer to the "WHEN REPLACING EEPROM (MEMORY) IC". POWER ON VOL. DOWN (Minimum) 8 2 sec. Check of the SUM DATA and MICON VERSION on the screen. Refer to the "WHEN REPLACING EEPROM (MEMORY) IC". POWER ON VOL. DOWN (Minimum) 9 2 sec. Display of the Adjustment MENU on the screen. Refer to the "ELECTRICAL ADJUSTMENT" (On-Screen Display Adjustment). Operations C-1 WHEN REPLACING EEPROM (MEMORY) IC CONFIRMATION OF CHECK SUM, POWER ON TOTAL HOURS AND MICON VERSION Initial total of MEMORY IC, POWER ON total hours and MICON VERSION can be checked on the screen. Total hours are displayed in 16 system of notation. NOTE: If you set a factory initialization, the total hours is reset to "0". Please refer to "CONFIRMATION OF INITIAL DATA" when SUM DATA is not corresponding. 1. Turn on the POWER,, and set to the ALL mode. 2. Set the VOLUME to minimum. 3. Press both VOL. DOWN button on the set and Channel button (8) on the remote control for more than 2 seconds. 4. After the confirmation of each check sum, turn off the power. NOTE: The each item value might be different according to each set. CHECK SUM : 504A Initial setting data check sum. LCD PWR ON : 0000 POWER ON total hours. = (16 x 16 x 16 x thousands digit value) + (16 x 16 x hundreds digit value) Main Micon check Version. EEPROM check Version. DTV : CA06I96182 + (16 x tens digit value) EEPROM : K39A05WM00 + (ones digit value) Parameter check Picture Quality. QUALITY : @@@@.@@ (@@@@@@ @@:@@:@@) Parameter check Picture Size. SCALING : @@@@.@@ (@@@@@@ @@:@@:@@) FIG. 1 CONFIRMATION OF INITIAL DATA If a service repair is undertaken where it has been required to change the MEMORY IC, the following steps should be taken to ensure correct data settings while making reference to INITIAL SETTING TABLE (Attached "INITIAL DATA"). 1. Turn on the POWER, and set to the ALL mode. 2. Set the VOLUME to minimum. 3. Press both VOL. DOWN button on the set and Channel button (6) on the remote control for more than 2 seconds. ADDRESS and DATA should appear as FIG 2. NOTE: No need to set data other position than 0D00~0EFF. ADDRESS INIT : 0001 DATA 0090 DTV : CA06I96182 EEPROM : K39A05WM00 FIG. 2 4. ADDRESS is now selected and should "blink". Using the CH. UP/DOWN buton on the remote, step through the ADDRESS until required ADDRESS to be changed is reached. 5. Press VOL. UP/DOWN button to select DATA. When DATA is selected, it will "blink". 6 Again 6. Again, step through the DATA using CH CH. UP/DOWN button until required DATA value has been selected selected. 7. Pressing VOL. UP/DOWN button will take you back to ADDRESS for further selection if necessary. 8. Repeat steps 4 to 6 until all data has been checked. 9. When satisfied correct DATA has been entered, turn POWER off (return to STANDBY MODE) to finish DATA input. After the data input, set to the initializing of shipping. 10. Turn on the Power. 11. Set the VOLUME to minimum. 12. Press both VOL. DOWN button on the set and Channel button (1) on the remote control for more than 2 seconds. 13. After the finishing of the initializing of shipping, the unit will turn off automatically. The unit will now have the correct DATA for the new MEMORY IC. C-2 ELECTRICAL ADJUSTMENTS 1. ADJUSTMENT PROCEDURE NO. 03 04 05 06 07 08 09 10 11 12 13 14 15 16 17 18 19 20 29 30 31 32 33 Read and perform these adjustments when repairing the circuits or replacing electrical parts or PCB assemblies. CAUTION • Use an isolation transformer when performing any service on this chassis. • When removing a PCB or related component, after unfastening or changing a wire, be sure to put the wire back in its original position. • When you exchange IC and Transistor with a heat sink, apply silicon grease(YG6260M) on the contact section of the heat sink. Before applying new silicon grease, remove all the old silicon grease. (Old grease may cause damage to the IC and Transistor). Prepare the following measurement tools for electrical adjustments. 1. Pattern Generator On-Screen Display Adjustment 1. Set the VOLUME to minimum. 2. Press the VOL. DOWN button on the set and the channel button (9) on the remote control for more than 2 seconds to display adjustment mode on the screen as shown in Fig. 1-1. FUNCTION R DRIVE(N) R CUTOFF(N) G DRIVE(N) G CUTOFF(N) B DRIVE(N) B CUTOFF(N) R DRIVE(C) R CUTOFF(C) G DRIVE(C) G CUTOFF(C) B DRIVE(C) B CUTOFF(C) R DRIVE(W) R CUTOFF(W) G DRIVE(W) G CUTOFF(W) B DRIVE(W) B CUTOFF(W) BAK LIGHT CENT BAK LIGHT MAX BAK LIGHT MIN BRIGHTNESS CENT BRIGHTNESS MAX NO. 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 58 FUNCTION BRIGHTNESS MIN TINT SHARP H1 MAX SHARP H1 MIN SHARP H2 MAX SHARP H2 MIN SHARP H3 MAX SHARP H3 MIN SHARP H4 MAX SHARP H4 MIN SHARP H5 MAX SHARP H5 MIN SHARP V1 MAX SHARP V1 MIN SHARP V2 MAX SHARP V2 MIN CONTRAST CENTER CONTRAST MAX CONTRAST MIN COLOR CENTER COLOR MAX COLOR MIN CONTRAST 40 Fig. 1-2 2. BASIC ADJUSTMENTS 2-1: WHITE BALANCE TV FULL Function 03 R DRIVE(N) 15 Step No. Fig. 1-1 3. Use the CH UP/DOWN button or Channel button (0-9) on the remote control to select the options shown in Fig. 1-2. 4. Press the MENU button on the remote control to end the adjustments. 5. To display the adjustment screen for TV, AV,COMPONENT HDMI and PC mode, press the INPUT SELECT button on the remote control. 6. Receive the DIGITAL broadcasting. 7. To display the adjustment screen fo DTV mode, select the digital channel. 8. Press the VOL.DOWN buttom on the set and the channel (9) on the remote control for more than 2 seconds. 1. Place the set in Aging Test for more than 30 minutes. 2. Receive the gray scale pattern from the Pattern Generator. 3. Press the INPUT SELECT button on the remote control to set to the AV mode. 4. Using the remote control, set the brightness and contrast to normal position. 5. Activate the adjustment mode display of Fig. 1-1 and press the channel button (03) on the remote control to select"R DRIVE (N)". 6. Press the UP/DOWN button on the remote control to select the "R CUTOFF (N)", "G DRIVE (N)", G CUTOFF (N), "B DRIVE (N)", "B CUTOFF (N)", R DRIVE (C), "R CUTOFF (C)", "G DRIVE (C)", G CUTOFF (C), "B DRIVE (C)", "B CUTOFF (C)", R DRIVE (W), "R CUTOFF (W)", "G DRIVE (W)", G CUTOFF (W), "B DRIVE (W)" or "B CUTOFF (W)". 7. Adjust the LEF/RIGHT button on the remote control to whiten the R CUTOFF (N), G DRIVE (N), G CUTOFF (N), B DRIVE (N), B CUTOFF (N), R DRIVE (C), R CUTOFF (C), G DRIVE (C), G CUTOFF (C), B DRIVE (C), B CUTOFF (C), R DRIVE (W), R CUTOFF (W), G DRIVE (W), G CUTOFF (W), B DRIVE (W) and B CUTOFF (W) at each step tone sections equally. 8. Perform the above adjustments 6 and 7 until the white color is achieved. D-1 ELECTRICAL ADJUSTMENTS 2-2: BRIGHTNESS CENT 2-3: CONTRAST MAX 1. Receive the color bar pattern. (RF Input) 2. Using the remote control, set the brightness and contrast to normal position. 3. Activate the adjustment mode display of Fig. 1-1 and press the channel button (32) on the remote control to select "BRIGHTNESS CENT". 4. Press the VOL.UP/DOWN button on the remote control until the contrast step No. becomes "130". 5. Check if the picture is normal. 6. Receive the color bar pattern. (VIDEO Input) 7. Press the INPUT SELECT button on the remote control to set to the AV mode. 8. Using the remote control, set the brightness and contrast to normal position. 9. Activate the adjustment mode display of Fig. 1-1 and press the channel button (32) on the remote control to select "BRIGHTNESS CENT". 10. Press the VOL.UP/DOWN button on the remote control until the contrast step No. becomes "131". 11. Check if the picture is normal. 12. Receive the color bar pattern. (S-VIDEO Input) 13. Press the INPUT SELECT button on the remote control to set to the AV(S) mode. 14. Using the remote control, set the brightness and contrast to normal position. 15. Activate the adjustment mode display of Fig. 1-1 and press the channel button (32) on the remote control to select "BRIGHTNESS CENT". 16. Press the VOL.UP/DOWN button on the remote control until the contrast step No No. becomes "131" 131 . 17. Check if the picture is normal. 18. Playback the DVD(480i) disc. (COMPONENT Input) 19. Press the INPUT SELECT button on the remote control to set to the COMPONENT mode. 20. Using the remote control, set the brightness and contrast to normal position. 21. Activate the adjustment mode display of Fig. 1-1 and press the channel button (32) on the remote control to select "BRIGHTNESS CENT". 22. Press the VOL.UP/DOWN button on the remote control until the contrast step No. becomes "132". 23. Check if the picture is normal. 24. Playback the DVD(480p) disc. (COMPONENT Input) 25. Press the INPUT button on the remote control to set to the COMPONENT mode. Then perform the above adjustments 20~23. 26. Playback the DVD(720p) disc. (COMPONENT Input) 27. Press the INPUT button on the remote control to set to the COMPONENT mode. Then perform the above adjustments 20~23. 28. Playback the DVD(1080i) disc. (COMPONENT Input) 29. Press the INPUT SELECT button on the remote control to set to the COMPONENT mode. Then perform the above adjustments 20~23. 1. Receive the color bar pattern. (RF Input) 2. Using the remote control, set the brightness and contrast to normal position. 3. Activate the adjustment mode display of Fig. 1-1 and press the channel button (51) on the remote control to select "CONTRANT MAX". 4. Press the VOL.UP/DOWN button on the remote control until the contrast step No. becomes "146". 5. Check if the picture is normal. 6. Receive the color bar pattern. (VIDEO Input) 7. Press the INPUT SELECT button on the remote control to set to the AV mode. 8. Using the remote control, set the brightness and contrast to normal position. 9. Activate the adjustment mode display of Fig. 1-1 and press the channel button (51) on the remote control to select "CONTRANT MAX". 10. Press the VOL.UP/DOWN button on the remote control until the contrast step No. becomes "152". 11. Check if the picture is normal. 12. Receive the color bar pattern. (S-VIDEO Input) 13. Press the INPUT SELECT button on the remote control to set to the AV(S) mode. Then perfrom the above adjustments 8~11. 14. Playback the DVD(480i) disc. (COMPONENT Input) 15. Press the INPUT SELECT button on the remote control to set to the COMPONENT mode. 16. Using the remote control, set the brightness and contrast to normal position. 17 Activate the adjustment mode display of Fig. 17. Fig 1 1-1 1 and press the channel button (51) on the remote control to select "CONTRANT MAX". 18. Press the VOL.UP/DOWN button on the remote control until the contrast step No. becomes "151". 19. Check if the picture is normal. D-2 ELECTRICAL ADJUSTMENTS 2-4: CONTRAST 40 2-5: CONTRAST CENTER 1. Receive the color bar pattern. (RF Input) 2. Using the remote control, set the brightness and contrast to normal position. 3. Activate the adjustment mode display of Fig. 1-1 and press the channel button (58) on the remote control to select "CONTRAST 40". 4. Press the VOL.UP/DOWN button on the remote control until the contrast step No. becomes "138". 5. Check if the picture is normal. 6. Receive the color bar pattern. (VIDEO Input) 7. Press the INPUT SELECT button on the remote control to set to the AV mode. 8. Using the remote control, set the brightness and contrast to normal position. 9. Activate the adjustment mode display of Fig. 1-1 and press the channel button (58) on the remote control to select "CONTRAST 40". 10. Press the VOL.UP/DOWN button on the remote control until the contrast step No. becomes "144". 11. Check if the picture is normal. 12. Receive the color bar pattern. (S-VIDEO Input) 13. Press the INPUT SELECT button on the remote control to set to the AV(S) mode. 14. Using the remote control, set the brightness and contrast to normal position. 15. Activate the adjustment mode display of Fig. 1-1 and press the channel button (58) on the remote control to select "CONTRAST 40". 16. Press the VOL.UP/DOWN button on the remote control until the contrast step No No. becomes "144" 144 . 17. Check if the picture is normal. 18. Playback the DVD(480i) disc. (COMPONENT Input) 19. Press the INPUT SELECT button on the remote control to set to the COMPONENT mode. 20. Using the remote control, set the brightness and contrast to normal position. 21. Activate the adjustment mode display of Fig. 1-1 and press the channel button (58) on the remote control to select "CONTRAST 40". 22. Press the VOL.UP/DOWN button on the remote control until the contrast step No. becomes "143". 23. Check if the picture is normal. 1. Receive the color bar pattern. (RF Input) 2. Using the remote control, set the brightness and contrast to normal position. 3. Activate the adjustment mode display of Fig. 1-1 and press the channel button (50) on the remote control to select "CONTRAST CENTER". 4. Press the VOL.UP/DOWN button on the remote control until the contrast step No. becomes "160". 5. Check if the picture is normal. 6. Receive the color bar pattern. (VIDEO Input) 7. Press the INPUT SELECT button on the remote control to set to the AV mode. 8. Using the remote control, set the brightness and contrast to normal position. 9. Activate the adjustment mode display of Fig. 1-1 and press the channel button (50) on the remote control to select "CONTRAST CENTER". 10. Press the VOL.UP/DOWN button on the remote control until the contrast step No. becomes "160". 11. Check if the picture is normal. 12. Receive the color bar pattern. (S-VIDEO Input) 13. Press the INPUT SELECT button on the remote control to set to the AV(S) mode. 14. Using the remote control, set the brightness and contrast to normal position. 15. Activate the adjustment mode display of Fig. 1-1 and press the channel button (50) on the remote control to select "CONTRAST CENTER". 16. Press the VOL.UP/DOWN button on the remote control until the contrast step No No. becomes "160" 160 . 17. Check if the picture is normal. 18. Playback the DVD(480i) disc. (COMPONENT Input) 19. Press the INPUT SELECT button on the remote control to set to the COMPONENT mode. 20. Using the remote control, set the brightness and contrast to normal position. 21. Activate the adjustment mode display of Fig. 1-1 and press the channel button (50) on the remote control to select "CONTRAST CENTER". 22. Press the VOL.UP/DOWN button on the remote control until the contrast step No. becomes "170". 23. Check if the picture is normal. D-3 ELECTRICAL ADJUSTMENTS 3. ELECTRICAL ADJUSTMENT PARTS LOCATION GUIDE (WIRING CONNECTION) LCD PANEL POWER PCB CP7001 CD2801 CP2804 CP8101 TU5801 CP4301 J8104 CD6202 J4302 CP4203 CP2803 SPEAKER DIGITAL PCB CP7601 AC IN CD501 J4206 J8102 J8103 J501 CD7602 CD301 J8101 CP501 CP3001 CP7002 OS7601 CP2201 REMOCON PCB OPERATION PCB D-6 TROUBLESHOOTING GUIDE (LCD SECTION) POWER DOES NOT TURN ON Is F501 broken? Yes Change F501. No Is there voltage at pin 6 of IC501 21V? No Check IC501 and peripheral circuit. Yes Change DIGITAL PCB. E-1 TROUBLESHOOTING GUIDE THE PICTURE APPEARS, BUT THE AUDIO DOES NOT APPEARS. (AT RF MODE) No Connect CD301. Is CD301 connected? Yes Is there signal at pins 1 and 4 of CD301? Yes Change SP301 and SP302. No Is there signal at pins 2 and 4 of IC301? Yes Check IC301 and peripheral circuit. No Is there signal at pins A3 and C4 of IC2801? Yes Check R2836, R2837 and peripheral circuit. Yes Check IC2801 and peripheral circuit. No Is there signal at pin 5 of TU5801? No Change TU5801. E-2 TROUBLESHOOTING GUIDE THE PICTURE DOES NOT APPEAR No Does backlight shine? Is CP7001 and CP7002 connected? No Connect CP7001 and CP7002. Yes Yes Is the voltage at pins 13, 15 of IC7001 8.3V? No Check IC7001 and peripheral circuit. Yes No Is CD2801 connected? Connect CD2801 Yes Is there voltage at pins 1, 2, 3, 16 and 17 of CP2804 5V? No Check Q3008 and peripheral circuit. Yes Is there signal at pins 7, 9, 10, 12, 13, 22, 23, 25, 26 and 28 of CP2804? Yes Change V2801(PANEL). No Change DIGITAL PCB. E-3 TROUBLESHOOTING GUIDE THE COLOR DOES NOT APPEAR Is setting of color normal? No Adjust the color. Yes Is the color signal received? No Receive the color signal. Yes Is there color signal at IC2801? No Check IC2801 and peripheral circuit. Yes Change DIGITAL PCB. E-4 IC DESCRIPTION R8J04012BG(IC2801) No. Ball NO. PIN NAME I/O 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 AB10 AA12 AB12 AB15 AA15 K3 H4 K4 Y12 Y13 AB11 J4 J3 H1 H3 G2 AB13 AB14 AA13 AB19 AB20 AA19 E1 F2 Y18 W15 F1 G3 G1 U21 U22 AB21 AA20 AB16 Y14 W13 AA14 AA16 Y15 AB17 AA17 Y16 AB18 W14 Y17 AA18 V20 V21 V22 U20 T19 V19 U19 W18 W17 T20 W22 W21 Y22 W20 RESET_N XIN25 XOUT25 Unused Unused Unused Unused Unused DVD_RESET EXT_MUTE S1_DET Unused SPDIF_OUT Unused SP_MUTE Unused Unused DVD_RXD DVD_TXD Unused Unused Unused TU_I2C_SCL TU_I2C_SDA E2P_I2C_SCL E2P_I2C_SDA IF_AGC Unused Unused LIGHT_CTL POWER_FAIL DEBUG_RXD DEBUG_TXD SFCK SFTX SFRX SFWP_N I I O O I O O O O I/O I O O O I/O O O I O O O O O I/O O I/O I O O O I I O O O I I/O I/O O I/O I/O O O O O O O I I I I I O O O O I O O O SFCS_N Unused USB_P USB_M Unused Unused Unused Unused Unused ASEBRKAK_N ASEMD0 TRST_N TCK TMS TDI TDO PANEL_POWER-H HDMI_HPD1 SYS_POWER-H TUNER_AFT Unused Unused Unused DESCRIPTION Reset in (Active Low) Main Clock in (25MHz) Main Clock out (25MHz) DVD Unit Reset Control (Active Low) Audio out Terminal Sound Mute (Active High) S Connector Detect SPDIF out Speaker Sound AMP Mute (Active High) DVD Unit Control UART Rx DVD Unit Control UART Tx Tuner Control I2C Bus Clock Tuner Control I2C Bus Data E2PROM Control I2C Bus Clock E2PROM Control I2C Bus Data Tuner IF AGC for Digital Backlight Control (PWM) Power Failure Detect (Active Low) For Debug For Debug Serial Flash Clock Serial Flash Transmit Serial Flash Receive Serial Flash Write Protect Serial Flash Chip Select For Software Update For Software Update E10A interface E10A interface JTAG Interface JTAG Interface JTAG Interface JTAG Interface JTAG Interface LCD Panel Power Control (Active High) HDMI1 Hot Plug Control (Active High) System Power Control (Active High) Tuner AFT Voltage in F-1 No. Ball NO. PIN NAME I/O 61 62 63 64 65 66 67 68 69 70 71 72 Y21 Y20 AA22 W19 H2 AA21 J2 T21 Y19 W16 J1 M1 KEY_A KEY_B DISC_IN_DET Unused STANDBY-L LIGHT_POWER-H Unused Unused REMOCON_IN HDMI_HPD2 Unused I2C_OFF I I I O O O O O I O O I 73 L1 AV_SW0 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100 101 102 103 104 105 106 107 108 109 110 111 112 113 114 115 116 117 118 119 120 121 M2 L2 K1 K2 W12 AA10 Y10 AA11 AB8 AB5 AB6 AA7 AA5 AA8 AB4 AA6 AA4 AB7 W5 W7 AB3 Y8 Y6 W9 R5 V7 AA2 Y2 AA1 W8 AB2 AA3 W6 Y4 N3 P2 N4 T2 R4 P4 R2 R3 R1 U3 N2 P1 V1 T4 AV_SW1 Unused Unused DVD-H Unused Unused Unused Unused SDA12 SDA11 SDA10 SDA9 SDA8 SDA7 SDA6 SDA5 SDA4 SDA3 SDA2 SDA1 SDA0 SDBA2 SDBA1 SDBA0 SDVREF0 SDVREF1 SDODT SDCLK SDCLK_N SDCKE SDRAS SDCAS SDWE SDCS SDDM1 SDDQ15 SDDQ14 SDDQ13 SDDQ12 SDDQ11 SDDQ10 SDDQ9 SDDQ8 SDDM0 SDDQS1 SDDQS1_N SDDQ7 SDDQ6 DESCRIPTION Local Key Detect A Local Key Detect B Disc In Detect Power LED Control (Active Low) Backlight Power Control (Active High) IR in for Remote Control HDMI2 Hot Plug Control (Active High) I2C Bus Stop Mode Control (Active Low) Audio Mode Switching Control (AV_SW0, AV_SW1) (Low, Low) DVD (Low, High) Video2, Component O (High, Low) PC, HDMI (High, High) Tuner, Video1 O O O O I O O I O O O O O O O O O O O O O O O O O O O O O O O O O I/O I/O I/O I/O I/O I/O I/O I/O I/O I/O I/O I/O I/O Refer to AV_SW0 (Ball No.L1) DVD Mode Switching Control (Active High) Always Pull-Up Always Open Always Pull-Down DDR2 Interface DDR2 Interface DDR2 Interface DDR2 Interface DDR2 Interface DDR2 Interface DDR2 Interface DDR2 Interface DDR2 Interface DDR2 Interface DDR2 Interface DDR2 Interface DDR2 Interface DDR2 Interface DDR2 Interface DDR2 Interface DDR2 Interface DDR2 Interface DDR2 Interface DDR2 Interface DDR2 Interface DDR2 Interface DDR2 Interface DDR2 Interface DDR2 Interface DDR2 Interface DDR2 Interface DDR2 Interface DDR2 Interface DDR2 Interface DDR2 Interface DDR2 Interface DDR2 Interface DDR2 Interface DDR2 Interface DDR2 Interface DDR2 Interface DDR2 Interface DDR2 Interface DDR2 Interface F-2 No. Ball NO. PIN NAME I/O 122 123 124 125 126 127 128 129 130 131 132 133 134 135 136 137 138 139 140 141 142 143 144 145 146 147 148 149 150 151 152 153 154 155 156 157 158 159 160 161 162 163 164 165 166 167 168 169 170 171 172 173 174 175 176 177 178 179 180 181 182 183 184 185 W2 V4 W3 W1 U4 V2 U2 U1 AA9 P21 P22 R21 R19 P19 N21 N19 R22 R20 P20 N22 N20 L19 L20 M21 L21 K21 K19 J21 M22 L22 K22 K20 J22 M19 B15 A15 C12 B13 A13 B12 A12 A11 B11 C11 D10 A10 B10 A9 B9 C10 D9 C9 A7 B7 A6 B8 B17 B16 D5 A4 B4 C6 B5 F20 SDDQ6 SDDQ5 SDDQ4 SDDQ3 SDDQ2 SDDQ1 SDDQ0 SDDQS0_N DD_CL LV0CKOP LV0CKOM LV0OUT4P LV0OUT3P LV0OUT2P LV0OUT1P LV0OUT0P LV0OUT4M LV0OUT3M LV0OUT2M LV0OUT1M LV0OUT0M LV1CKOP LV1CKOM LV1OUT4P LV1OUT3P LV1OUT2P LV1OUT1P LV1OUT0P LV1OUT4M LV1OUT3M LV1OUT2M LV1OUT1M LV1OUT0M REFR SSIN1 SSIN2 LPF VIN1A VIN2A VIN3A VIN4A VIN5A VIN6A VREFA REXT VIN1B VIN2B VIN3B VIN4B VREFB VRP VRM VIN1C VIN2C VIN3C VREFC HSIN VSIN SIFIN VSBINP VSBINM VRPVSA VRMVSA RXC0M I/O I/O I/O I/O I/O I/O I/O I/O I/O O O O O O O O O O O O O O O O O O O O O O O O O P I I P I I I I I I P P I I I I P P P I I I P I I I I I P P I DESCRIPTION DDR2 Interface DDR2 Interface DDR2 Interface DDR2 Interface DDR2 Interface DDR2 Interface DDR2 Interface DDR2 Interface LVDS clock out+ #0 LVDS clock out- #0 LVDS data out 4+ #0 LVDS data out 3+ #0 LVDS data out 2+ #0 LVDS data out 1+ #0 LVDS data out 0+ #0 LVDS data out 4- #0 LVDS data out 3- #0 LVDS data out 2- #0 LVDS data out 1- #0 LVDS data out 0- #0 LVDS clock out+ #1 LVDS clock out- #1 LVDS data out 4+ #1 LVDS data out 3+ #1 LVDS data out 2+ #1 LVDS data out 1+ #1 LVDS data out 0+ #1 LVDS data out 4- #1 LVDS data out 3- #1 LVDS data out 2- #1 LVDS data out 1- #1 LVDS data out 0- #1 External resistance Video sync slicer input #1 Video sync slicer input #1 Video PLL low pass filter Video in Video in Video in Video in Video in Video in Video in External resistance Video in Video in Video in Video in Video reference voltage Video reference voltage Video reference voltage Video in Video in Video in Video reference voltage H sync in V sync in SIF input Digital IF in + Digital IF in Reference voltage Reference voltage HDMI clock in - ch#0 F-3 No. Ball NO. PIN NAME I/O 186 187 188 189 190 191 192 193 194 195 196 197 198 199 200 201 202 203 204 205 206 207 208 209 210 211 212 213 214 215 216 217 218 219 220 221 222 223 224 225 226 227 228 229 230 231 232 233 234 235 236 237 238 239 240 241 242 243 244 245 246 247 248 249 F19 E21 E20 D22 D21 C22 C21 H21 H20 G21 G22 F21 F22 G20 G19 D20 D19 B22 B21 B22 B21 A22 A21 E18 A17 B18 C17 D16 D17 A18 A19 C18 B19 H19 J18 H18 B2 C3 A1 C4 A3 D4 E11 E13 E9 A16 C8 D11 B3 E3 E5 D7 E7 A14 A8 D12 D8 E10 E12 E8 A2 B1 D3 C5 RXC0P RX00M RX00P RX10M RX10P I I I I I I I I I I I I I I I I I I I I I I I I I I I I I/O I I/O I I/O P P P I P I O O P P P P P P P P P P P P G G G G G G G G G G G RX20M RX20P RXC1M RXC1P RX01M RX01P RX11M RX11P RX21M RX21P RXC2M RXC2P RX02M RX02P RX12M RX12P RX22M RX22P EXT_RES PWR0 PWR1 PWR2 DDC0_SCL DDC0_SDA DDC1_SCL DDC1_SDA DDC2_SCL DDC2_SDA PLL_XFC_A PLL_XFC_X PLL_XFC_P AINL VCOM AINR DA_LOUT DA_ROUT DA_VCOM AVDD18 AVDD18 AVDD18 AVDD33 AVDD33 AVDD33 AVDD33AUA AVDD33AUA AVDD33AUD AVDD33VSA AVDD33VSA AVSS AVSS AVSS AVSS AVSS AVSS AVSS AVSSAUA AVSSAUA AVSSAUA AVSSAUD DESCRIPTION HDMI clock in + ch#0 HDMI data 0 - ch#0 HDMI data 0 + ch#0 HDMI data 1 - ch#0 HDMI data 1 + ch#0 HDMI data 2 - ch#0 HDMI data 2 + ch#0 HDMI clock in - ch#1 HDMI clock in + ch#1 HDMI data 0 - ch#1 HDMI data 0 + ch#1 HDMI data 1 - ch#1 HDMI data 1 + ch#1 HDMI data 2 - ch#1 HDMI data 2 + ch#1 HDMI clock in - ch#2 HDMI clock in + ch#2 HDMI data 0 - ch#2 HDMI data 0 + ch#2 HDMI data 1 - ch#2 HDMI data 1 + ch#2 HDMI data 2 - ch#2 HDMI data 2 + ch#2 External resistance HDMI PWR in ch#0 HDMI PWR in ch#1 HDMI PWR in ch#2 HDMI DDC SCL ch#0 HDMI DDC SDA ch#0 HDMI DDC SCL ch#1 HDMI DDC SDA ch#1 HDMI DDC SCL ch#2 HDMI DDC SDA ch#2 HDMI PLL filter HDMI PLL filter HDMI PLL filter Audio A/D converter in L Audio reference voltage Audio A/D converter in R Audio D/A converter out L Audio D/A converter out R Audio reference voltage Video ADC power Video ADC power Video ADC power Video ADC power Video ADC power Video ADC power Audio ADC power Audio ADC power Audio DAC power ADC power ADC power Video ADC ground Video ADC ground Video ADC ground Video ADC ground Video ADC ground Video ADC ground Video ADC ground Audio ADC ground Audio ADC ground Audio ADC ground Audio DAC ground F-4 No. Ball NO. PIN NAME I/O 250 251 252 253 254 255 256 257 258 259 260 261 262 263 264 265 266 267 268 269 270 271 272 273 274 275 276 277 278 279 280 281 282 283 284 285 286 287 288 289 290 291 292 293 294 295 296 297 298 299 300 301 302 303 304 305 306 307 308 309 310 311 312 313 E4 A5 D6 C14 D13 Y11 W11 V11 V12 W10 V10 N18 R18 C13 B14 L18 J20 T18 N1 N5 T1 T5 V3 Y1 Y5 Y9 H5 K5 V14 V18 K10 K12 K9 L10 L13 L14 L3 L4 L5 L9 M14 M3 M4 M5 M9 N14 N9 P12 P14 P9 V15 V17 V6 V8 E14 J10 J11 J12 J9 K11 E15 J13 K14 F18 AVSSAUD AVSSVSA AVSSVSA DLLVDD DLLVSS PLL1AVCC PLL1DVDD PLL2AVCC PLL2DVDD PLL3AVCC PLL3DVDD PLL4AVCC PLL4DVDD PLLVDD PLLVSS VCC33BIAS VCC33LVDS VCC33LVDS VCCQ18 VCCQ18 VCCQ18 VCCQ18 VCCQ18 VCCQ18 VCCQ18 VCCQ18 VCCQ33 VCCQ33 VCCQ33 VCCQ33 VDD VDD VDD VDD VDD VDD VDD VDD VDD VDD VDD VDD VDD VDD VDD VDD VDD VDD VDD VDD VDD VDD VDD VDD Reserved VDD18 VDD18 VDD18 VDD18 VDD18 VDD18HDMI VDD18HDMI VDD18HDMI VDD33_PLL G G G P G P P P P P P P P P G P P P P P P P P P P P P P P P P P P P P P P P P P P P P P P P P P P P P P P P P P P P P P P P P DESCRIPTION Audio DAC ground ADC ground ADC ground DLL power DLL ground PLL power PLL power PLL power PLL power PLL power PLL power PLL power PLL power PLL power PLL ground LVDS BIAS power LVDS power LVDS power DDR2 power DDR2 power DDR2 power DDR2 power DDR2 power DDR2 power DDR2 power DDR2 power Digital IO power Digital IO power Digital IO power Digital IO power Digital core power Digital core power Digital core power Digital core power Digital core power Digital core power Digital core power Digital core power Digital core power Digital core power Digital core power Digital core power Digital core power Digital core power Digital core power Digital core power Digital core power Digital core power Digital core power Digital core power Digital core power Digital core power Digital core power Digital core power Do not connect any signals. 1.8V power 1.8V power 1.8V power 1.8V power 1.8V power HDMI power HDMI power HDMI power HDMI power F-5 No. Ball NO. PIN NAME I/O 314 315 316 317 318 319 320 321 322 323 324 325 326 327 328 329 330 331 332 333 334 335 336 337 338 339 340 341 342 343 344 345 346 347 348 349 350 351 352 353 354 355 356 357 358 359 360 361 362 363 364 365 366 367 368 369 370 371 372 373 374 375 376 K18 B20 E16 E22 D15 C16 AB1 AB22 AB9 D1 J5 L11 L12 M10 M11 M12 M13 N10 N11 N12 N13 P10 P11 P13 P18 P3 P5 T3 U18 U5 V13 V16 V5 V9 W4 Y3 Y7 M18 M20 T22 A20 E17 G18 H22 J14 K13 J19 C15 D14 C7 E19 E6 B6 C1 C2 D18 D2 E2 F3 F4 F5 G4 G5 VDD33_PLL VDD33HDMI VDD33HDMI VDD33HDMI VDD33IO VPPOTP VSS VSS VSS VSS VSS VSS VSS VSS VSS VSS VSS VSS VSS VSS VSS VSS VSS VSS VSS VSS VSS VSS VSS VSS VSS VSS VSS VSS VSS VSS VSS VSS33BIAS VSS33LVDS VSS33LVDS VSSHDMI VSSHDMI VSSHDMI VSSHDMI VSSHDMI VSSHDMI VSSHDMI VSSIO VSSIO Reserved Reserved Reserved NC NC NC NC NC NC NC NC NC NC NC P P P P P P G G G G G G G G G G G G G G G G G G G G G G G G G G G G G G G G G G G G G G G G G G G G G G - DESCRIPTION HDMI power HDMI power HDMI power HDMI power HDMI power HDMI power Digital ground Digital ground Digital ground Digital ground Digital ground Digital ground Digital ground Digital ground Digital ground Digital ground Digital ground Digital ground Digital ground Digital ground Digital ground Digital ground Digital ground Digital ground Digital ground Digital ground Digital ground Digital ground Digital ground Digital ground Digital ground Digital ground Digital ground Digital ground Digital ground Digital ground Digital ground LVDS BIAS ground LVDS ground LVDS ground HDMI ground HDMI ground HDMI ground HDMI ground HDMI ground HDMI ground HDMI ground HDMI ground HDMI ground Do not connect any signals. Do not connect any signals. Do not connect any signals. Not connected. Not connected. Not connected. Not connected. Not connected. Not connected. Not connected. Not connected. Not connected. Not connected. Not connected. F-6 SEMICONDUCTOR BASE CONNECTIONS DIODE 1H3-A2 1H6-A2 1SS133T-77 MTZJ12B T-77 MTZJ33B T-77 SARS01-V1 31DQ10-FC ZRM11C 1N4005-EIC RU2AM-EIC EC11FS2-TE12L SMAB34 LTL-1CHEE-002A IC S10K150E2S5M4 BAT54WS UDZSNP22B TE-17 UDZSNP33B TE-17 UDZSNP9.1B TE-17 MBRF1045CT 8 5 AT24C256BN-SH-T TC74LVX4052FT AT25DF321-SU BD9323EFJ FA5571N-D1-TE1 LA5797M TE L E LA5797M-TE-L-E UP7704U8 1 23 1 1 1 MA111-(TX) R3111N291C-TR-F KIA431A-AT S-1170B50UC-OUJTFG 1 BD9893F-E2 1 LA42052-E TRANSISTOR E B CE 1 PS2561AL1-1-V(W) D D S D G D SI3443BDV-T1-E3 H5PS5162FFR-S5C R8J04012BG C KRA101SRTK KRA103SRTK KRC102SRTK KTC3198-AT(Y,GR) DD D D G S G S FW256-TL-E G-1 B KRC103SRTK KTA1504S_Y_RTK KTC3875S_Y_RTK G DS KHB9D0N50F2-U/P MECHANICAL REPLACEMENT PARTS LIST REF. NO. PART NO. 101 101A 101B 7A701B329A 701WPJD847 713WPA0434 713WPAA291 800WQ00181 FRONT CABI ASS'Y CABINET FRONT GLASS LED GLASS LED FELT SHEET 7A702A969A 7A702A954A 7A702A970A 7A702B002A 702WPAB537 761WSA0709 BACK CABI ASS'Y BACK CABI ASS'Y BACK CABI ASS'Y BACK CABI ASS'Y CABINET BACK ANGLE BACK 103B 7A7040108A 704WPBA110 704WPBA111 704WPBA124 800WRA0009 STAND ASS'Y STAND STAND STAND CUSHION LEG 104 104A 104B 7A711A179A 711WPDA913 735WPAB189 PANEL SIDE ASS'Y PANEL SIDE BUTTON FRAME 105 106 107 108 109 752WSA0737 704WPA0123 706WPA0031 722465A542 7230007075 SHIELD DIGITAL STAND FRAME COVER CONNECTOR SHEET RATING SHEET INFORMATION 110 114 744WUA0038 744WUAA005 761WPAA235 761WPA0554 702WPA1438 702WPAB497 800WQ0A060 SPRING EARTH-3 SPRING EARTH-3 HOLDER LCD HOLDER LVDS-3 COVER INVERTER COVER INVERTER FELT SHEET 201 202 203 204 205 206 8109I30A0U 8109D30A0U 8109230A0U 8109230A4U 8110K3080U 8117140B5U SCREW SCREW SCREW SCREW SCREW SCREW --- 791WHA0189 791WHA0192 792WHA0782 792WHAA320 792WHAA342 792WHAA346 792WHA0783 792WHAA321 792WHAA343 792WHAA347 793WCDE207 795WCAA943 795WCA0733 8905000001 FILM BAG FILM BAG PACKAGE TOP PACKAGE TOP PACKAGE TOP PACKAGE TOP PACKAGE BOTTOM PACKAGE BOTTOM PACKAGE BOTTOM PACKAGE BOTTOM GIFT BOX PAD PAD SCREW 101C 102 102A 102B 103 103A 111 112 113 --- --- ------- DESCRIPTION or or or or or or TAP TITE(B) WH7 TAP TITE(B) WH8 TAP TITE(B) BIND TAP TITE(B) BIND TAP TITE(P) LAMI TAPPING(B0) PAN or or 3x10 3x10 3x10 3x14 HEAD 3x8 4x25 or or or or or or or or ACCESSORY REPLACEMENT PARTS LIST REF. NO. PART NO. TM101 ! CD501 ------- 076E0RC011 120Q119905 J34C1129A J39A0501A JA5K0000 DESCRIPTION TRANSMITTER CORD SET AC INFORMATION SHEET(RETURN) INSTRUCTION BOOK(EN) POLYBAG,INSTRUCTION M1-1 CR48D00 P201-2476-2 ELECTRICAL REPLACEMENT PARTS LIST REF. NO. PART NO. R302 R304 R305 R306 R307 R313 R501 R502 R503 R504 R505 R506 R507 R508 R509 R510 R511 R512 R513 R515 R517 R518 R519 R523 R524 R525 R529 R531 R533 R535 R536 R538 R543 R544 R545 R546 R547 R549 R2202 R2203 R2204 R2205 R2206 R2802 R2803 R2804 R2805 R2807 R2808 R2809 R2812 R2813 R2815 R2816 R2817 R2818 R2819 R2820 R2822 R2823 R2824 R2825 R2828 R2829 R2830 R2831 R2832 R2835 R2836 R2837 R2838 R2839 R2841 R2842 R2843 R2844 R2845 R803R9102J R803R9222J R803R9222J R803R9222J R803R9222J R002T4101J R002T2223J R002T4103J RC31X1126J R002T2223J R63884330J R803R9333J R803R9101J R002T4101J RC31X1125J R3K781010J R002T4150J R3K781563J R002T4823J R803R9102J R002T4222J R002T4101J R803R9103J R803R9222F R803R9911F R803R9222F R002T4222J R803R9103J R803R9103F R002T4822J R803R9224F R803R9103J R803R9223J R861R41R2F R861R41R2F R861R41R2F R861R41R2F R803R7102J R803R9821J R803R9153J R803R9562J R803R9562J R803R9821J R808R9103J R808R9103J R808R9103J R808R9103J R808R9472J R808R9182J R808R9181F R808R9472J R808R9472J R808R9220J R808R9220J R808R9220J R808R9220J R808R9220J R808R9105J R808R9104J R808R9222J R808R9103J R808R9103J R808R9472J R808R9102F R808R9102F R808R9121J R808R9330J R808R9472J R808R9243J R808R9243J R808R9472J R808R9472J R808R9330J R808R94R7J R808R94R7J R808R9820F R808R9102F ! ! ! ! ! ! ! ! ! DESCRIPTION RESISTORS RC RC RC RC RC RC RC RC RC RC R,FUSE RC RC RC RC R,METAL OXIDE RC R,METAL OXIDE RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC 1K OHM 1/16W 2.2K OHM 1/16W 2.2K OHM 1/16W 2.2K OHM 1/16W 2.2K OHM 1/16W 100 OHM 1/4W 22K OHM 1/2W 10K OHM 1/4W 12M OHM 1W 22K OHM 1/2W 33 OHM 1/4W 33K OHM 1/16W 100 OHM 1/16W 100 OHM 1/4W 1.2M OHM 1W 1 OHM 1W 15 OHM 1/4W 56K OHM 1W 82K OHM 1/4W 1K OHM 1/16W 2.2K OHM 1/4W 100 OHM 1/4W 10K OHM 1/16W 2.2K OHM 1/16W 910 OHM 1/16W 2.2K OHM 1/16W 2.2K OHM 1/4W 10K OHM 1/16W 10K OHM 1/16W 8.2K OHM 1/4W 220K OHM 1/16W 10K OHM 1/16W 22K OHM 1/16W 1 2 OHM 1/4W 1.2 1.2 OHM 1/4W 1.2 OHM 1/4W 1.2 OHM 1/4W 1K OHM 1/10W 820 OHM 1/16W 15K OHM 1/16W 5.6K OHM 1/16W 5.6K OHM 1/16W 820 OHM 1/16W 10K OHM 1/16W 10K OHM 1/16W 10K OHM 1/16W 10K OHM 1/16W 4.7K OHM 1/16W 1.8K OHM 1/16W 180 OHM 1/16W 4.7K OHM 1/16W 4.7K OHM 1/16W 22 OHM 1/16W 22 OHM 1/16W 22 OHM 1/16W 22 OHM 1/16W 22 OHM 1/16W 1M OHM 1/16W 100K OHM 1/16W 2.2K OHM 1/16W 10K OHM 1/16W 10K OHM 1/16W 4.7K OHM 1/16W 1K OHM 1/16W 1K OHM 1/16W 120 OHM 1/16W 33 OHM 1/16W 4.7K OHM 1/16W 24K OHM 1/16W 24K OHM 1/16W 4.7K OHM 1/16W 4.7K OHM 1/16W 33 OHM 1/16W 4.7 OHM 1/16W 4.7 OHM 1/16W 82 OHM 1/16W 1K OHM 1/16W REF. NO. PART NO. R2846 R2847 R2848 R2849 R2850 R2851 R2852 R2853 R2854 R2856 R2857 R2858 R2859 R2860 R2861 R2862 R2863 R2866 R2867 R2868 R2873 R2874 R2876 R2879 R2882 R2883 R2894 R2896 R2901 R2906 R2915 R2916 R2917 R2918 R2919 R2920 R2927 R3004 R3012 R3017 R3021 R3023 R3024 R3027 R3029 R3030 R3034 R3037 R3038 R3039 R3040 R3057 R3058 R3059 R3060 R3431 R3600 R3602 R3603 R3605 R3606 R3609 R3610 R3613 R3616 R3618 R3619 R3621 R3623 R3624 R3626 R3627 R3628 R3629 R3630 R3631 R3654 M2-1 R808R9102F R808R9562F R808R9220J R808R9103J R808R9220J R808R9103J R808R9102F R808R9102F R808R9102F R808R9682F R808R9272J R808R9272J R808R9332J R808R9332J R808R9102J R808R9153J R808R9472J R808R9472J R808R9472J R808R9103J R808R9472J R808R9472J R808R9472J R808R9472J R808R9472J R808R9472J R808R9220J R808R9220J R808R9103J R808R9103J R808R9472J R808R9472J R808R9332J R808R9103J R808R9103J R808R9103J R808R9153J R808R9102J R808R9682J R808R9822J R808R9470J R808R9103J R808R9332J R808R9102J R808R9393J R808R9103F R808R9103F R808R9332F R808R9392F R808R9101F R808R9562F R808R9433J R808R9102F R808R9273F R808R9681F R808R9471J R808R9103J R808R9103J R808R9103J R808R9103J R808R9103J R808R9103J R808R9103J R808R9103J R808R9103J R808R9103J R808R9103J R808R9103J R808R9473J R808R9473J R808R9473J R808R9473J R808R9473J R808R9473J R808R9473J R808R9473J R808R9561J DESCRIPTION RESISTORS RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC 1K OHM 1/16W 5.6K OHM 1/16W 22 OHM 1/16W 10K OHM 1/16W 22 OHM 1/16W 10K OHM 1/16W 1K OHM 1/16W 1K OHM 1/16W 1K OHM 1/16W 6.8K OHM 1/16W 2.7K OHM 1/16W 2.7K OHM 1/16W 3.3K OHM 1/16W 3.3K OHM 1/16W 1K OHM 1/16W 15K OHM 1/16W 4.7K OHM 1/16W 4.7K OHM 1/16W 4.7K OHM 1/16W 10K OHM 1/16W 4.7K OHM 1/16W 4.7K OHM 1/16W 4.7K OHM 1/16W 4.7K OHM 1/16W 4.7K OHM 1/16W 4.7K OHM 1/16W 22 OHM 1/16W 22 OHM 1/16W 10K OHM 1/16W 10K OHM 1/16W 4.7K OHM 1/16W 4.7K OHM 1/16W 3.3K OHM 1/16W 10K OHM 1/16W 10K OHM 1/16W 10K OHM 1/16W 15K OHM 1/16W 1K OHM 1/16W 6.8K OHM 1/16W 8.2K OHM 1/16W 47 OHM 1/16W 10K OHM 1/16W 3.3K OHM 1/16W 1K OHM 1/16W 39K OHM 1/16W 10K OHM 1/16W 10K OHM 1/16W 3.3K OHM 1/16W 3.9K OHM 1/16W 100 OHM 1/16W 5.6K OHM 1/16W 43K OHM 1/16W 1K OHM 1/16W 27K OHM 1/16W 680 OHM 1/16W 470 OHM 1/16W 10K OHM 1/16W 10K OHM 1/16W 10K OHM 1/16W 10K OHM 1/16W 10K OHM 1/16W 10K OHM 1/16W 10K OHM 1/16W 10K OHM 1/16W 10K OHM 1/16W 10K OHM 1/16W 10K OHM 1/16W 10K OHM 1/16W 47K OHM 1/16W 47K OHM 1/16W 47K OHM 1/16W 47K OHM 1/16W 47K OHM 1/16W 47K OHM 1/16W 47K OHM 1/16W 47K OHM 1/16W 560 OHM 1/16W ELECTRICAL REPLACEMENT PARTS LIST REF. NO. PART NO. R3657 R4235 R4238 R4245 R4246 R4247 R4249 R4250 R4251 R4252 R4254 R4257 R4258 R4261 R4262 R4263 R4265 R4316 R4317 R4318 R4319 R5803 R5804 R5805 R5806 R5807 R5808 R5809 R5814 R5815 R5816 R5817 R5824 R6207 R6208 R6503 R6504 R6506 R6507 R6508 R6509 R6510 R6511 R7001 R7002 R7003 R7004 R7005 R7010 R7011 R7012 R7013 R7014 R7015 R7016 R7017 R7018 R7019 R7021 R7022 R7023 R7024 R7025 R7026 R7027 R7028 R7030 R7031 R7032 R7038 R7039 R7047 R7602 R7604 R7605 R8103 R8104 R808R9103J R808R9222J R808R9101J R808R9152J R808R9332J R808R9101J R808R9221J R808R9101J R808R9680J R808R9332J R808R9332J R808R9104J R808R9222J R808R9750J R808R9222J R808R9750J R808R9750J R808R9102J R808R9102J R808R9563J R808R9563J R808R9154J R808R9473J R808R9104J R808R9101J R808R9101J R808R9101J R808R9101J R808R9332J R808R9332J R808R9102J R808R9101J R808R9102J R808R9103J R808R9472J R808R9153J R808R9153J R808R9153J R808R9103J R808R9103J R808R9153J R808R9153J R808R9153J R803R9272J R803R9223J R803R9472J R803R9102J R803R9101J R803R9393F R002T4104J R002T4471J R803R9683J R002T4153J R803R9223J R803R9223J R803R9223F R803R9122J R002T4471J R803R9274J R002T4332J R002T4220J R002T4220J R803R9393F R803R9822F R803R9153J R803R9104F R803R9153F R803R9272F R803R9333J R002T4330J R002T4330J R803R9103J R803R9470J R803R9391J R803R9101J R803R9750J R803R9750J DESCRIPTION RESISTORS RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC 10K OHM 1/16W 2.2K OHM 1/16W 100 OHM 1/16W 1.5K OHM 1/16W 3.3K OHM 1/16W 100 OHM 1/16W 220 OHM 1/16W 100 OHM 1/16W 68 OHM 1/16W 3.3K OHM 1/16W 3.3K OHM 1/16W 100K OHM 1/16W 2.2K OHM 1/16W 75 OHM 1/16W 2.2K OHM 1/16W 75 OHM 1/16W 75 OHM 1/16W 1K OHM 1/16W 1K OHM 1/16W 56K OHM 1/16W 56K OHM 1/16W 150K OHM 1/16W 47K OHM 1/16W 100K OHM 1/16W 100 OHM 1/16W 100 OHM 1/16W 100 OHM 1/16W 100 OHM 1/16W 3.3K OHM 1/16W 3.3K OHM 1/16W 1K OHM 1/16W 100 OHM 1/16W 1K OHM 1/16W 10K OHM 1/16W 4.7K OHM 1/16W 15K OHM 1/16W 15K OHM 1/16W 15K OHM 1/16W 10K OHM 1/16W 10K OHM 1/16W 15K OHM 1/16W 15K OHM 1/16W 15K OHM 1/16W 2.7K OHM 1/16W 22K OHM 1/16W 4.7K OHM 1/16W 1K OHM 1/16W 100 OHM 1/16W 39K OHM 1/16W 100K OHM 1/4W 470 OHM 1/4W 68K OHM 1/16W 15K OHM 1/4W 22K OHM 1/16W 22K OHM 1/16W 22K OHM 1/16W 1.2K OHM 1/16W 470 OHM 1/4W 270K OHM 1/16W 3.3K OHM 1/4W 22 OHM 1/4W 22 OHM 1/4W 39K OHM 1/16W 8.2K OHM 1/16W 15K OHM 1/16W 100K OHM 1/16W 15K OHM 1/16W 2.7K OHM 1/16W 33K OHM 1/16W 33 OHM 1/4W 33 OHM 1/4W 10K OHM 1/16W 47 OHM 1/16W 390 OHM 1/16W 100 OHM 1/16W 75 OHM 1/16W 75 OHM 1/16W REF. NO. PART NO. R8105 R8106 R8107 R8108 R8110 R8111 R8112 R8113 R8114 R8115 R8116 R8117 R8118 R8119 R8120 R803R9750J R803R9750J R803R9750J R803R9750J R803R9102J R803R9101J R803R9101J R803R9102J R803R9102J R803R9101J R803R9102J R803R9102J R803R9101J R803R9101J R803R9101J C301 C302 C303 C304 C305 C306 C307 C309 C310 C311 C323 C501 C502 C503 C504 C505 C506 C507 C508 C509 C510 C511 C513 C514 C516 C518 C519 C520 C521 C522 C523 C525 C526 C531 C534 C538 C539 C543 C545 C546 C2801 C2805 C2807 C2808 C2809 C2810 C2811 C2812 C2813 C2814 C2815 C2816 C2817 C2818 C2819 C2820 C2821 C2822 C2823 C2824 C2825 CS0PB0N16K CS0PB0415K CS0PB0N16K E7ESU2101M CS0PCH4Q2J CS0PCH4Q2J E7ESU5100M E7EST2471M E7EST2471M E7EST2471M E7ESU54R7M CS0PB04E4K E82DFC151M CS0PCH4Q1J E8E1F1222D CS0PCH4W1J P4K12D224K CE39E0M13M P4K12D104K CS0PB0415K CRGTB0415K E7ESU2221M C0PLRR713K CE39E0MQ2K E7ESU5470M P332E4223J C03L0R7H2K E8E2U54R7D P232W0184J E8E1T2471M P1S3T0472J E8E1F3102M CS0PB0413K CS0PB0316K CE39E0M13M CS0PB03E5K CS0PB03E5K E7ESU5100M CS0PB02E5K CS0PB02E5K CS0UB0N15K CS0UB0214K CS0UCH4H1J CS0UCH4H1J CS0UB0N15K CS0UB0N15K CS0RB0N17K CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0UB0N15K DESCRIPTION RESISTORS RC RC RC RC RC RC RC RC RC RC RC RC RC RC RC 75 75 75 75 1K 100 100 1K 1K 100 1K 1K 100 100 100 OHM 1/16W OHM 1/16W OHM 1/16W OHM 1/16W OHM 1/16W OHM 1/16W OHM 1/16W OHM 1/16W OHM 1/16W OHM 1/16W OHM 1/16W OHM 1/16W OHM 1/16W OHM 1/16W OHM 1/16W CAPACITORS ! ! ! ! ! ! ! ! ! ! ! ! M2-2 CC CC CC CE CC CC CE CE CE CE CE CC CE CC CE CC CMPP CC CMPP CC CC CE CC CC CE CPP CC CE CMPL CE CP CE CC CC CC CC CC CE CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC 1 UF 10V B 0.1 UF 50V B 1 UF 10V B 100 UF 16V 470 PF 50V CH 470 PF 50V CH 10 UF 50V 470 UF 16V 470 UF 16V 470 UF 16V 4.7 UF 50V 0.015 UF 50V B 150 UF 200V 47 PF 50V CH 2200 UF 10V 82 PF 50V CH 0.22 UF 310V 0 001 UF 250V E 0.001 0.1 UF 310V 0.1 UF 50V B 0.1 UF 50V B 220 UF 16V 0.001 UF 2KV R 470 PF 250V E 47 UF 50V 0.022 UF 400V 220 PF 2KV R 4.7 UF 50V 0.18 UF 50V MMTS 470 UF 16V 0.0047UF 50V 1000 UF 25V 0.001 UF 50V B 1 UF 25V B 0.001 UF 250V E 0.15 UF 25V B 0.15 UF 25V B 10 UF 50V 0.15 UF 16V B 0.15 UF 16V B 0.1 UF 10V B 0.01 UF 16V B 22 PF 50V CH 22 PF 50V CH 0.1 UF 10V B 0.1 UF 10V B 10 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B ELECTRICAL REPLACEMENT PARTS LIST REF. NO. PART NO. C2826 C2827 C2828 C2829 C2830 C2831 C2832 C2833 C2834 C2835 C2836 C2837 C2838 C2839 C2840 C2841 C2842 C2843 C2844 C2845 C2846 C2848 C2851 C2854 C2855 C2856 C2857 C2858 C2859 C2860 C2861 C2862 C2863 C2864 C2865 C2866 C2867 C2868 C2869 C2870 C2871 C2872 C2873 C2874 C2875 C2876 C2877 C2878 C2879 C2880 C2881 C2882 C2883 C2884 C2885 C2888 C2889 C2891 C2895 C2902 C2903 C2904 C2905 C2906 C2907 C2908 C2909 C2911 C2912 C2913 C2914 C2915 C2916 C2917 C2918 C2919 C2925 CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0UB0N15K E66UM0331D E66UM1220D CS0RB0N17K CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0UB0N15K E66UM0331D CS0UB0N15K E61UMQ331D CS0RB0N17K CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0RB0N17K CS0RB0N17K CS0RB0N17K CS0RB0N17K CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0PB0NQ5K CS0UB0N15K CS0UB0N15K CS0UB0214K CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0RB0N17K CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0RB0N17K CS0UB0N15K CS0UB0N15K CS0RB0N17K DESCRIPTION CAPACITORS CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CE CE CC CC CC CC CC CE CC CE CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 330 UF 6.3V 22 UF 10V 10 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 330 UF 6.3V 0.1 UF 10V B 330 UF 4V 10 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 10 UF 10V B 10 UF 10V B 10 UF 10V B 10 UF 10V B 0 1 UF 10V B 0.1 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.47 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.01 UF 16V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 10 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 10 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 10 UF 10V B REF. NO. PART NO. C2926 C2927 C2928 C2929 C2930 C2932 C2933 C2934 C2936 C2937 C2938 C2939 C2940 C2943 C2944 C2945 C2946 C2948 C2950 C2951 C2952 C2953 C2954 C2955 C2956 C2957 C2958 C2959 C2960 C2961 C2962 C2963 C2976 C2985 C2986 C3004 C3012 C3015 C3017 C3018 C3019 C3021 C3023 C3024 C3027 C3028 C3030 C3032 C3033 C3034 C3035 C3038 C3039 C3041 C3044 C3045 C3046 C3047 C3048 C3049 C3050 C3051 C3607 C4230 C4236 C4240 C4247 C5803 C5804 C5808 C5809 C5811 C5814 C5815 C5818 C5819 C5827 M2-3 CS0RB0N17K CS0RB0N17K CS0RB0N17K CS0RB0N17K E61UMQ331D CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0PB0N16K CS0PB0N16K CS0UB0N15K CS0RB0N17K CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0UB0N15K E66UM1220D CS0UB0N15K CS0UB0413K CS0UB0413K CS0UB0N15K CS0UB0N15K CS0RB0216K E61UMQ331D CS0UB0413K CS0UB0413K CS0RB0N17K CS0UB0413K CS0RB0N17K CS0RB0N17K CS0RB0N17K CS0UB0NH5K CS0RB0PH7M CS0RB0PH7M CS0RB0PH7M CS0RB0N17K CS0UB0N15K CS0UB0413K CS0UB0N15K CS0UB0N15K CS0UB04L3K CS0UB0N15K CS0RB0N17K CS0UB0P16K CS0UB0413K CS0RB0N17K CS0UB0N15K CS0UB0N15K CS0UB0413K E71GMM151D CS0RB0N17K CS0UB0214K CS0UB0N15K CS0UB0N16K CS0UB0N15K CS0UCH412J CS0UB0413K E964M0221D CS0UB0N15K CS0PB0415K CS0UCH4Q1J CS0UCH4Q1J CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0UB0214K DESCRIPTION CAPACITORS CC CC CC CC CE CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CE CC CC CC CC CC CC CE CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CE CC CC CC CC CC CC CC CE CC CC CC CC CC CC CC CC 10 UF 10V B 10 UF 10V B 10 UF 10V B 10 UF 10V B 330 UF 4V 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 1 UF 10V B 1 UF 10V B 0.1 UF 10V B 10 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 22 UF 10V 0.1 UF 10V B 0.001 UF 50V B 0.001 UF 50V B 0.1 UF 10V B 0.1 UF 10V B 1 UF 16V B 330 UF 4V 0.001 UF 50V B 0.001 UF 50V B 10 UF 10V B 0.001 UF 50V B 10 UF 10V B 10 UF 10V B 10 UF 10V B 0.22 UF 10V B 22 UF 6.3V B 22 UF 6.3V B 22 UF 6.3V B 10 UF 10V B 0.1 UF 10V B 0.001 UF 50V B 0.1 UF 10V B 0.1 UF 10V B 0.0033UF 50V B 0.1 UF 10V B 10 UF 10V B 1 UF 6.3V B 0.001 UF 50V B 10 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.001 UF 50V B 150 UF 2V 10 UF 10V B 0.01 UF 16V B 0.1 UF 10V B 1 UF 10V B 0.1 UF 10V B 100 PF 50V CH 0.001 UF 50V B 220 UF 6.3V 0.1 UF 10V B 0.1 UF 50V B 47 PF 50V CH 47 PF 50V CH 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 0.01 UF 16V B ELECTRICAL REPLACEMENT PARTS LIST REF. NO. PART NO. DESCRIPTION CAPACITORS C5828 C5829 C5830 C5831 C5832 C5833 C5834 C5835 C5836 C6201 C6202 C6210 C6213 C6501 C6503 C6505 C6510 C6514 C6516 C6518 C7001 C7002 C7003 C7004 C7007 C7008 C7009 C7010 C7011 C7012 C7017 C7018 C7020 C7022 C7026 C7030 C7031 C7032 C7033 C7602 C8102 C8103 C8104 C8105 C8106 C8107 C8108 C8109 C8110 C8111 CS0UB0214K CS0UB0NL5K CS0UB0P16K CS0UCH4S1J CS0UB0N15K CS0UB0N15K CS0UB0N15K CS0UCH411J CS0UCH4L1J CS0UB0215K CS0UB0215K CS0UB0214K CS0PB0N16K CS0PB0N16K CS0PB0N16K E66VM2101D CS0PB0N16K CS0PB0N16K CS0PB0N16K CS0PB0N16K CS0PB0315K CS0PB04Q3K CS0PB02U4K CS0PB0413K CS0PB04Q3K CS0PB0NQ5K CS0PB0315K CS0PB0415K CS0PB0316K CS0PCH4H2J C0JTB05H3K C0JTB05H3K CS0PB0414K CS0SB0317K CS0SB0317K C339SLBB1J CS0PB0414K CS0PB0414K C339SLBB1J E70QU0101M CS0PCH412J CS0PCH412J CS0PCH4Q2J CS0PCH412J CS0PCH4Q2J CS0PCH4Q2J CS0PCH4Q2J CS0PCH412J CS0PCH412J CS0PCH4Q2J CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CE CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CC CE CC CC CC CC CC CC CC CC CC CC D501 D504 D505 D506 D507 D508 D509 D510 D511 D512 D514 D515 D516 D517 D518 D519 D520 D521 D522 D523 D526 D527 D528 D3001 D3002 D3003 DE7RB3302B D7KE101520 D2WXN40050 D28R11FS20 D4JXRM11C0 D4JXRM11C0 DE7RB3302B D4JXRM11C0 D4CT01H6A0 D2BXARS010 D2WXRU2AM0 D28F31DQ10 D4CT01H3A0 D97U01201B D4JXRM11C0 DGERMA1110 DGERMA1110 DGERMA1110 DGERMA1110 D2AA045CT0 DE7RB2202B D97U03301B D97U03301B D2ARMAB340 D2ARMAB340 D2ARMAB340 DIODE ZENER DIODE VARISTA DIODE SILICON DIODE DIODE SILICON DIODE SILICON DIODE ZENER DIODE SILICON DIODE RECTIFIER DIODE SILICON DIODE SILICON DIODE SCHOTTKY DIODE RECTIFIER DIODE,ZENER DIODE SILICON DIODE SILICON DIODE SILICON DIODE SILICON DIODE SILICON DIODE SCHOTTKY BARRIER DIODE ZENER DIODE,ZENER DIODE,ZENER DIODE SCHOTTKY DIODE SCHOTTKY DIODE SCHOTTKY 0.01 UF 16V B 0.33 UF 10V B 1 UF 6.3V B 56 PF 50V CH 0.1 UF 10V B 0.1 UF 10V B 0.1 UF 10V B 10 PF 50V CH 33 PF 50V CH 0.1 UF 16V B 0.1 UF 16V B 0.01 UF 16V B 1 UF 10V B 1 UF 10V B 1 UF 10V B 100 UF 16V 1 UF 10V B 1 UF 10V B 1 UF 10V B 1 UF 10V B 0.1 UF 25V B 0.0047UF 50V B 0.068 UF 16V B 0.001 UF 50V B 0.0047UF 50V B 0.47 UF 10V B 0.1 UF 25V B 0.1 UF 50V B 1 UF 25V B 220 PF 50V CH 0.0022UF 500V B 0.0022UF 500V B 0.01 UF 50V B 10 UF 25V B 10 UF 25V B 12 PF 6KV SL 0.01 UF 50V B 0.01 UF 50V B 12 PF 6KV SL 100 UF 6.3V 100 PF 50V CH 100 PF 50V CH 470 PF 50V CH 100 PF 50V CH 470 PF 50V CH 470 PF 50V CH 470 PF 50V CH 100 PF 50V CH 100 PF 50V CH 470 PF 50V CH DIODES ! ! ! ! ! ! ! ! ! ! UDZSNP33B TE-17 S10K150E2S5M4 1N4005-EIC EC11FS2-TE12L ZRM11C ZRM11C UDZSNP33B TE-17 ZRM11C 1H6-A2 SARS01-V1 RU2AM-EIC 31DQ10-FC 1H3-A2 MTZJ12B T-77 ZRM11C MA111-(TX) MA111-(TX) MA111-(TX) MA111-(TX) MBRF1045CT UDZSNP22B TE-17 MTZJ33B T-77 MTZJ33B T-77 SMAB34 SMAB34 SMAB34 REF. NO. PART NO. DESCRIPTION DIODES D3004 D3006 D3403 D6204 D6206 D7003 D7004 D7012 D7013 D7014 D7017 D7018 D7024 D7601 D2ARMAB340 D2ARMAB340 DGERMA1110 DGJRT54WS0 DGERMA1110 DE7RB9R12B DGERMA1110 D1VT001330 DGERMA1110 DGERMA1110 DGERMA1110 DGERMA1110 DGERMA1110 0021E2Q140 DIODE SCHOTTKY DIODE SCHOTTKY DIODE SILICON DIODE SCHOTTKY BARRIER DIODE SILICON DIODE ZENER DIODE SILICON DIODE,SILICON DIODE SILICON DIODE SILICON DIODE SILICON DIODE SILICON DIODE SILICON LED SMAB34 SMAB34 MA111-(TX) BAT54WS MA111-(TX) UDZSNP9.1B TE-17 MA111-(TX) 1SS133T-77 MA111-(TX) MA111-(TX) MA111-(TX) MA111-(TX) MA111-(TX) LTL-1CHEE-002A IC301 IC501 IC502 IC503 IC505 IC2801 IC2802 IC2803 IC2804 IC2806 LA42052-E FA5571N-D1-TE1 VARIABLE SHUNT REGULATOR TAPE KIA431A-AT CHARGE POMP CONTROL LA5797M-TE-L-E PS2561AL1-1-V(W) PHOTO COUPLER SCALER C5+ R8J04012BG H5PS5162FFR-S5C DDR2-800 512M CL=5 IC3004 IC3006 IC3007 IC3008 IC6201 IC6501 IC7001 I03SP20520 ICAL055710 I1KJ9A431A I03F9797M0 000220002W I56M040120 IGXM05162E S39A06JE02 ----ICRJ0C2560 ICRJ0256B0 I5HJ950UC0 I07F993230 I07F993230 IGRF0704U0 IC7J0291C0 I55J040520 I07F098930 ! Q501 Q503 Q504 Q505 Q2805 Q2806 Q3001 Q3002 Q3003 Q3004 Q3005 Q3008 Q3407 Q4204 Q4307 Q6502 Q6504 Q7001 Q7002 ! Q7004 TJA0N50FS0 TPAAC05002 TNAAC05002 TAAA1504SY TCAA3875SY TCAA3875SY TNAAB05003 TPAAA05001 TNAAB05003 TCAA3875SY TNAAC05002 TK9A3443B0 TNAAB05003 TCAA3875SY TPAAC05002 TNAAC05002 TNAAC05002 TCAA3875SY TCATC31980 TS3M000040 FET COMPOUND TRANSISTOR COMPOUND TRANSISTOR TRANSISTOR SILICON TRANSISTOR SILICON TRANSISTOR SILICON COMPOUND TRANSISTOR COMPOUND TRANSISTOR COMPOUND TRANSISTOR TRANSISTOR SILICON COMPOUND TRANSISTOR FET COMPOUND TRANSISTOR TRANSISTOR SILICON COMPOUND TRANSISTOR COMPOUND TRANSISTOR COMPOUND TRANSISTOR TRANSISTOR SILICON TRANSISTOR,SILICON COMPOUND TRANSISTOR ! L502 L503 L504 L3002 L3003 L3008 L5803 L5804 ! T501 ! T7001 029X000420 02167E220K 02167E100K 021AMG100M 021AMG100M 021AMG100M 021AS9224J 0216SD220J 0481280258 048137001R COIL,LINE FILTER COIL COIL COIL COIL COIL COIL COIL TRANSFORMER,SWITCHING TRANSFORMER,SWITCHING ! J501 J4206 J4302 J8101 J8102 J8103 J8104 064Q1A0014 060R401140 060R131024 062R750007 060R411058 060R431039 060R431040 JACK,AC RCA JACK HEADPHONE JACK PLUG RCA JACK RCA JACK RCA JACK 0504101T34 0504101T34 SWITCH,TACT SWITCH,TACT ICS ! ! ! ! ! ! ! ! ! SOUND AMP 5W 2CH POWER IC CONTROL MEMORY DATA EEPROM 256K I2C AT24C256BN-SH-T MEMORY DATA FLASH 32M SPI 8PIN AT25DF321-SU AT24C256BN-SH-T EEPROM 256K I2C EEPROM 256K 12C AT24C256BN-10SU-1.8 REGULATOR VO=5.0V IO=800MA S-1170B50UC-OUJTFG DC-DC CONVERTER 3.0A DC-DC CONVERTER 3.0A BD9323EFJ BD9323EFJ UP7704U8 R3111N291C-TR-F TC74LVX4052FT BD9893F-E2 2A DROPOUT LINEAR REGULATOR RESET IC 2.9 V TYPE CMOS DUAL 4CH ANALOG MULTIPLEXER INVERTER CONTROL IC TRANSISTORS KHB9D0N50F2-U/P KRA103SRTK KRC103SRTK KTA1504S_Y_RTK KTC3875S_Y_RTK KTC3875S_Y_RTK KRC102SRTK KRA101SRTK KRC102SRTK KTC3875S_Y_RTK KRC103SRTK SI3443BDV-T1-E3 KRC102SRTK KTC3875S_Y_RTK KRA103SRTK KRC103SRTK KRC103SRTK KTC3875S_Y_RTK KTC3198-AT(Y,GR) FW256-TL-E COILS &TRANSFORMERS SS11VL-R10093 22 UH 10 UH 10 UH 10 UH 10 UH 0.22 UH 22 UH 81280258 8137001R JACKS CCT2302-0921FC RCA-101HT(OR) PJ-364H DIN-417HA-01 RCA-341H(NI)-09 RCA-228H(3)NI-02 RCA-341H(2)NI-06 SWITCHES SW2202 SW2203 M2-4 EVQ21505R EVQ21505R or ELECTRICAL REPLACEMENT PARTS LIST REF. NO. PART NO. SW2204 SW2205 SW2206 SW2207 SW2208 0504101T34 0504101T34 0504101T34 0504101T34 0504101T34 DESCRIPTION SWITCHES SWITCH,TACT SWITCH,TACT SWITCH,TACT SWITCH,TACT SWITCH,TACT REF. NO. PART NO. EVQ21505R EVQ21505R EVQ21505R EVQ21505R EVQ21505R P.C.BOARD ASSEMBLIES PCB240 A39A05W240 POWER PCB ASS'Y PCB270 A39A06J270 OPERATION PCB ASS'Y PCBDA0 A39A06JDA0 REMOCON PCB ASS'Y PCBDH0 A39A05WDH0 DIGITAL PCB ASS'Y CEH434A CEH438A CEH439A CEJ483A MISCELLANEOUS B304 B305 B501 B2801 B2802 B2803 B2805 B2807 B2809 B2810 B2811 B2812 B2813 B2814 B2817 B2818 B3016 B3601 B4215 B5803 B5804 B5805 B6201 B6202 B6203 B6503 BT001 BT002 CD301 CP501 CD2801 CD6202 CD7602 CP2201 CP2801 CP2802 CP2803 CP2804 CP3001 CP4203 CP4301 CP7001 CP7002 CP7601 CP8101 EL2401 EL2402 ! F501 ! F7001 FH501 FH502 NR2801 NR2802 NR2803 NR2804 NR2805 NR2814 NR2815 NR3601 NR3602 024HC13914 024HC13914 024HT03564 024HC52213 024HC52216 024HC52216 024HC51816 024HC52216 024HC52216 024HC52216 024BC5121J 024BC5121J 024BC5121J 024BC5121J 024BC5121J 024BC5121J 024HC51816 024HC51816 024HC56005 024HC51023 024HC51023 024BC5121J 024HC51023 024HC51023 024HC51023 024HC52213 141U004021 141U004021 06CP143403 06977NM020 06EH2U2512 06CP231504 06CP250804 069S230639 06GG270029 06GG2B0029 06GFAA1004 06GG2U0051 06CK7N0301 06G7S21501 06CK7N0301 069SJ20019 069SJ20019 069S250629 06977NM020 124116281A 124120301A 081PC04005 0835C04003 067A0T0011 067A0T0011 110P4330M5 110P4330M5 110P4330M5 110P4220M5 110P4220M5 110P4330M5 110P4330M5 110P4473M5 110P4473M5 CORE,BEADS CORE,BEADS CORE,BEADS CORE,BEADS CORE,BEADS CORE,BEADS CORE,BEADS CORE,BEADS CORE,BEADS CORE,BEADS CORE,BEADS CORE,BEADS CORE,BEADS CORE,BEADS CORE,BEADS CORE,BEADS CORE,BEADS CORE,BEADS CORE,BEADS CORE,BEADS CORE,BEADS CORE,BEADS CORE BEADS CORE,BEADS CORE,BEADS CORE,BEADS CORE,BEADS BATTERY,MANGAN BATTERY,MANGAN CORD CONNECTOR CONNECTOR PCB SIDE CORD CONNECTOR CORD CONNECTOR CORD CONNECTOR CONNECTOR PCB SIDE CONNECTOR PCB SIDE CONNECTOR PCB SIDE CONNECTOR PCB SIDE CONNECTOR PCB SIDE CORD CONNECTOR CONNECTOR PCB SIDE CORD CONNECTOR CONNECTOR PCB SIDE CONNECTOR PCB SIDE CONNECTOR PCB SIDE CONNECTOR PCB SIDE EYE LET EYE LET FUSE MICRO FUSE HOLDER,FUSE HOLDER,FUSE R,NETWORK R,NETWORK R,NETWORK R,NETWORK R,NETWORK R,NETWORK R,NETWORK R,NETWORK R,NETWORK HCB3216KF-391T20 HCB3216KF-391T20 W4BRH3.5X6X1.0 FCM1608KF-221T05 HCB1608KF-221T20 HCB1608KF-221T20 HCB1608KF-181T20 HCB1608KF-221T20 HCB1608KF-221T20 HCB1608KF-221T20 BLM18PG121SN1D BLM18PG121SN1D BLM18PG121SN1D BLM18PG121SN1D BLM18PG121SN1D BLM18PG121SN1D HCB1608KF-181T20 HCB1608KF-181T20 FCM1608CF-600T06 FCM1608KF-102T02 FCM1608KF-102T02 BLM18PG121SN1D FCM1608KF 102T02 FCM1608KF-102T02 FCM1608KF-102T02 FCM1608KF-102T02 FCM1608KF-221T05 AAA(R03) AAA(R03) CP143403 127301123K2 EH2U2512 CP231504 CP250804 A2001WR2-3P A2001WV-7A A2001WV-11A UA11-04010B140-R A2006WV30 TWG-P23P-A1 WD-00021-R TWG-P23P-A1 C3502WR0-2P-HK C3502WR0-2P-HK A2001WV2-5P 127301123K2 XRY16X28BD XRY20X30BD 51MS040L 20N_4000FS CNT47-0003A CNT47-0003A 4D02WGJ0330TCE 4D02WGJ0330TCE 4D02WGJ0330TCE 4D02WGJ0220TCE 4D02WGJ0220TCE 4D02WGJ0330TCE 4D02WGJ0330TCE 4D02WGJ0473TCE 4D02WGJ0473TCE ! ! ! ! ! DESCRIPTION MISCELLANEOUS NR3605 110P4473M5 R,NETWORK NR3606 110P4473M5 R,NETWORK NR6501 110P4223M5 R,NETWORK NR6502 110P4223M5 R,NETWORK NR6503 110P4223M5 R,NETWORK NR6504 110P4223M5 R,NETWORK OS7601 077Q038009 REMOTE RECEIVER SP301 070Y433007 SPEAKER SP302 070Y433007 SPEAKER TH501 DSQDNE5R0L THERMISTOR TU5801 0164100027 DIGITAL TUNER V2801 A39A05W360 LCD MODULE ASS'Y X2801 100GT02509 CRYSTAL 4D02WGJ0473TCE 4D02WGJ0473TCE 4D02WGJ0223TCE 4D02WGJ0223TCE 4D02WGJ0223TCE 4D02WGJ0223TCE KSM-2003TCW2P S0308F05 S0308F05 5D2-08LCS ENG36E18KRF M185B1-P01-CL01-OR1 SMD-49 C25000H025 RESISTOR RC................... CARBON RESISTOR CAPACITORS CC................... CERAMIC CAPACITOR CE................... ALUMI ELECTROLYTIC CAPACITOR CP................... POLYESTER CAPACITOR CPP.................. POLYPROPYLENE CAPACITOR CPL.................. PLASTIC CAPACITOR CMP.................. METAL POLYESTER CAPACITOR CMPL................ METAL PLASTIC CAPACITOR CMPP................ METAL POLYPROPYLENE CAPACITOR M2-5 HOW TO ORDER PARTS When placing a parts order, please have the following information. A. MODEL NUMBER and VERSION NUMBER Located on the back of the unit. EX: VR0100 (Model no.), VERSION/A (Version no.) B. PART NO. and DESCRIPTION Located in your SERVICE MANUAL. ( See pages M1-1~M2-5) STK5342, Voltage Regulator EX: I235953420, PART NO. DESCRIPTION C. QUANTITY D. Mailing address and NAME EX: ABC Service Center 111 Broadway NEW YORK, N.Y. 10005 ATTN: MR. X Y Z ORION SALES, INC. HIGHWAY 41 ORION PLACE PRINCETON, INDIANA 47670