Download Dell D1920F Service manual
Transcript
DELL E173FP Service Manual SERVICE MANUAL 17” LCD Monitor DELL E173FP THESE DOCUMENTS ARE FOR REPAIR SERVICE INFORMATION ONLY. EVERY REASONABLE EFFORT HAS BEEN MADE TO ENSURE THE ACCURACY OF THIS MANUAL; WE CANNOT GUARANTEE THE ACCURACY OF THIS INFORMATION AFTER THE DATE OF PUBLICATION AND DISCLAIMS RE LIABILITY FOR CHANGES, ERRORS OR OMISSIONS. Prepared By: WuHaiyan Checked By: Sushi Manufacture Date: May-29-04 1 DELL E173FP Service Manual Table of Contents Table of Contents -----------------------------------------------------------------------------------------------2 1. MONITOR SPECIFICATIONS -----------------------------------------------------------------------------4 2. LCD MONITOR DESCRIPTION -----------------------------------------------------------------------------5 3. OPERATING INSTRUCTIONS --------------------------------------------------------------------------6 3.1 GENERAL INSTRUCTIONS ----------------------------------------------------------------------------6 3.2 CONTROL BUTTONS ----------------------------------------------------------------------------------------6 3.3 ADJUSTING THE PICTURE ----------------------------------------------------------------------------7 4. Input/Output Specification--------------------------------------------------------------------------------------10 4.1 Input Signal Connector ----------------------------------------------------------------------------------------10 4.1.1 Analog D-SUB Connector ----------------------------------------------------------------------------------10 4.2 Factory Preset Display Modes ----------------------------------------------------------------------------10 4.3 Power Supply Requirements ----------------------------------------------------------------------------11 4.3.1 Input Requirements --------------------------------------------------------------------------------------11 4.3.2 Output Requirements----------------------------------------------------------------------------------------11 4.4 PANEL SPECIFICATION -------------------------------------------------------------------------------------11 4.4.1 Panel Feature ----------------------------------------------------------------------------------------------11 4.4.2 Display Characteristics ----------------------------------------------------------------------------------11 4.4.3 Optical Characteristics --------------------------------------------------------------------------------12 4.4.4 Parameter guide line for CCFL Inverter --------------------------------------------------------------12 5. Block Diagram ----------------------------------------------------------------------------------------------------13 5.1 Monitor Exploded View ----------------------------------------------------------------------------------------13 5.2 Software Flow Chart ----------------------------------------------------------------------------------------14 5.3 Electrical Block Diagram --------------------------------------------------------------------------------16 5.3.1 Main Board ----------------------------------------------------------------------------------------------------16 5.3.2 Inverter/Power Board ----------------------------------------------------------------------------------------17 6. Schematic ----------------------------------------------------------------------------------------------------------18 6.1 Main Board --------------------------------------------------------------------------------------------------18 6.2 Inverter/Power Board --------------------------------------------------------------------------------------23 2 DELL E173FP Service Manual 7. PCB Layout ----------------------------------------------------------------------------------------------------25 7.1 Main Board --------------------------------------------------------------------------------------------------25 7.2 Inverter/Power Board --------------------------------------------------------------------------------------26 7.3 Keypad Board----------------------------------------------------------------------------------------------------28 8. Maintainability -----------------------------------------------------------------------------------------------------29 8.1 Equipments and Tools Requirements ---------------------------------------------------------------------29 8.2 Trouble Shooting -----------------------------------------------------------------------------------------------30 8.2.1 Main Board ----------------------------------------------------------------------------------------------------30 8.2.2 Power/Inverter Board ---------------------------------------------------------------------------------------33 8.2.3 Key Pad Board ------------------------------------------------------------------------------------------------35 9. White-Balance, Luminance adjustment ---------------------------------------------------------------------36 10. EDIT Content ----------------------------------------------------------------------------------------------38 11. ISP User Manual-------------------------------------------------------------------------------------------------39 11.1. Connect ISP Writer preparation action-------------------------------------------------------------------39 11.2. To Use ISP WRITER-----------------------------------------------------------------------------------------39 11.3. Executing ISP--------------------------------------------------------------------------------------------------43 12. BOM List ----------------------------------------------------------------------------------------------------------44 3 DELL E173FP Service Manual 1. MONITOR SPECIFICATIONS Driving system LCD Panel Input TFT Color LCD Size 43cm(17.0") Pixel pitch 0.264mm(H) x 0.264mm(V) Viewable angle 140˚ (H) 120˚ (V) Response time (typ.) 16 ms Video Analog Only Sync. Type H/V TTL Separate and Composite Sync. H-Frequency 30kHz – 80kHz V-Frequency 56-75Hz Display Colors Over 16.2 million Colors Dot Clock 135MHz Max. Resolution 1280 x 1024 Plug & Play VESA DDC2BTM Power Consumption ON Mode <35W Power Saving <2W Maximum Screen Size Horizontal : 337.92mm Vertical: 270.336mm Power Source 90~264VAC,47~63Hz Environmental Considerations Operating Temp: 0°C to 50°C Storage Temp.: -20°C to 60°C Operating Humidity: 10% to 90% Weight (N. W.) Packaged 5.8Kgs Unit Unpackaged 4.6Kgs Unit 4 DELL E173FP Service Manual 2. LCD MONITOR DESCRIPTION The LCD MONITOR will contain a main board, an internal inverter/power board, keypad board, which house the flat panel control logic, brightness control logic and DDC. The internal Inverter/power board will drive the backlight of panel and the DC-DC conversion. and provides the 12V DC-power to main board. Monitor Block Diagram Flat Panel and CCFT Driver. CCFL backlight Main Board Inverter/Power Board RS232 Connector For white balance adjustment in Keyboard AC Power IN HOST Computer 5 factory mode Video signal, DDC DELL E173FP Service Manual 3. OPERATING INSTRUCTIONS 3.1 GENERAL INSTRUCTIONS Press the power button to turn the monitor on or off. The other control buttons are located at front panel of the monitor. By changing these settings, the picture can be adjusted to your personal preferences. - The power cord should be connected. - Connect the video cable from the monitor to the video card. - Press the power button to turn on the monitor, the power indicator will light up. 3.2 CONTROL BUTTONS - Power Button: When pressed, the monitor enters the off mode, and the LED turns blank. Press again to restore normal status. - Brightness Button: The Brightness Button is used to select the Brightness/Contrast adjust functions. or adjust settings. - Auto Adjust Key: The Auto Adjust Key is used to automatically set the H Position, V Position, Clock and Phase. - Power Indicator: Green — Power On mode. Orange — Power Saving mode. Blank —Power Off Mode. Control Buttons A. Buttons for the OSD menu (On-Screen-display) B. Brightness Button C. Auto Adjust Button D. Power On/Off Button and indicator 6 Press to switch functions DELL E173FP Service Manual 3.3 ADJUSTING THE PICTURE To set the OSD menu, perform the following steps: Briefly press the SELCT / MENU button to activate the OSD menu. The main menu appears on the screen with icons for the setting functions. The first symbol (Exit) is highlighted. Necessary, press the - or + button to mark another icon (e.g. Positioning). Press the SELECT/MENU button to select the highlighted icon. The corresponding setting window (here: Positioning) is displayed. The first symbol (Exit) is highlighted. If necessary, press the – or + button to mark the desired icon. Press the SELECT/MENU button to select the highlighted function. Press the – or + button to adjust the value for the selected function. Press the SELECT/MENU button to exit the function. Press the SELECT/MENU button to exit the sub-menu when “Exit” function is highlighted; All changes are stored automatically. Adjusting the brightness and contrast Calling the Brightness / Contrast setting window using Brightness button. Brightness Setting the brightness of the display With this function you change the brightness of the background lighting. Contrast Setting the contrast of the display With this function you modify the contrast of bright colour tones. 7 DELL E173FP Service Manual Adjusting size and position Calling the Positioning setting window H-Position Adjusting the horizontal position With this function you move the picture to the left or to the right. V-Position Adjusting the vertical position With this function you move the picture up or down. Setting Image Calling the Image setting window Auto Adjust Auto adjust will produce best image automatically, The information of “ Auto Adjust In Progress” will show; Pixel clock Adjusting the pixel clock Phase Adjusting the phase Setting colour temperature and colours Calling the Color setting window Selecting the colour temperature The colour temperature is measured in K (= Kelvin). You can select from Normal Preset, Blue Preset, Red Preset to User Preset; Normal preset = Original colour of the LCD display, it’s 6500K; Blue preset =5700Kcolour of the LCD display, it’s 9300K; Red preset =9300K colour of the LCD display, it’s 5700K; User preset = Setting user-defined colours In the user preset setting you can change the colour ratios of the basic colours (red, green, blue) as required. Setting display of the OSD menu Calling the OSD Set up setting window Horizontal Setting the horizontal position of the OSD menu Position With this function you move the OSD menu to the left or to the right. Vertical Setting the vertical position of the OSD menu Position With this function you move the OSD menu up or down. 8 DELL E173FP Service Manual OSD Hold Time Setting the display duration of the OSD menu With this function you select a value from 0 to 60 seconds. If the set time expires without a setting being made, the OSD menu is automatically faded out. OSD Setting the display of the OSD menu lock or unlock. Lock With this function you select Yes to lock OSD, NO to unlock it. Setting Language Calling the Language setting window With this function you choose between English (default setting), French, German, Spanish and Japanese as the language for the OSD menu. Factory Reset Activating the factory settings With this function all settings except Language of OSD are reset to the factory settings without prompting for confirmation. 9 DELL E173FP Service Manual 4. Input/Output Specification 1 6 2 7 3 8 4 9 5 10 4.1 Input Signal Connector 4.1.1 Analog D-SUB Connector 15 14 13 12 16 11 17 Pin Meaning Pin Meaning 1 Video input red 9 +5 V (DDC) 2 Video input green 10 VGA-PG 3 Video input blue 11 Ground 4 Ground 12 DDC-Data 5 Ground 13 H. Sync 6 Red video ground 14 V. Sync 7 Green video ground 15 DDC Clock 8 Blue video ground 4.2 Factory Preset Display Modes The following are the most frequently used of the preset operating modes: Horizontal frequency Refresh rate Screen resolution 31.5 kHz 70 Hz 720 x 400 31.5 kHz 60 Hz 640 x 480 37.5 kHz 75 Hz 640 x 480 37.9 kHz 60 Hz 800 x 600 46.9 kHz 75 Hz 800 x 600 48.4 kHz 60 Hz 1024 x 768 60.0 kHz 75 Hz 1024 x 768 67.5KHz 75Hz 1152 x 864 64.0KHz 60Hz 1280 x 1024 79.9KHz 75Hz 1280 x 1024 For ergonomic reasons, a screen resolution of 1280 x 1024 pixels is recommended. Because of the technology used (active matrix) an LCD monitor provides a totally flicker-free picture even with a refresh rate of 60 Hz. 10 DELL E173FP Service Manual 4.3 Power Supply Requirements 4.3.1 Input Requirements AC INPUT VOLTAGE: 90V ~ 264V AC INPUT FREQUENCY: 47 ~ 63 HZ AC INPUT CURRENT: 1.5A max. INRUSH CURRENT: 60A MAX AT 264VAC COLD START LEAKAGE CURRENT: 3.5 mA MAX and less then 0.25 mA at 100Vac 4.3.2 Output Requirements ITEM MIN. TYP. MAX. UNIT Output voltage (12V) 11.4 12 12.6 V Output current (12V) 0 2.0 3.0 A Output voltage ( 5V) 4.75 5.0 5.25 V Output current (5V) 0 1.5 2.0 A Ripple & Noise (12V) 200 mV Ripple & Noise (5V) 100 mV REMARK 4.4 PANEL SPECIFICATION 4.4.1 Panel Feature -High contrast ratio, high aperture structure -Wide viewing angle -High-speed response -SXGA (1280 x 1024 pixels) resolution -Low power consumption 4.4.2 Display Characteristics Items Display Area Driver element Display color Number of pixels Pixel Arrangement Pixel pitch Display Mode Specification 337.92x270.336 a-Si TFT active matrix 16.2M 1280 x 1024 RGB vertical stripe 0.264(H) x 0.264(W) Normally Black 11 Unit mm Colors pixel mm DELL E173FP Service Manual 4.4.3 Optical Characteristics The optical characteristics are measured under stable conditions at 25℃ (Room Temperature): 4.4.4 Parameter guide line for CCFL Inverter 12 DELL E173FP Service Manual 5. Block Diagram 5.1 Monitor Exploded View 13 DELL E173FP Service Manual 5.2 Software Flow Chart 1 Y 2 3 N 4 N 5 Y 6 N 7 8 Y 9 10 N N 11 Y 12 Y 14 13 Y 15 Y 17 18 N 19 Y 14 N N 16 DELL E173FP Service Manual 1) MCU Initializes. 2) Is the EEprom blank? 3) Program the EEprom by default values. 4) Get the PWM value of brightness from EEprom. 5) Is the power key pressed? 6) Clear all global flags. 7) Are the AUTO and SELECT keys pressed? 8) Enter factory mode. 9) Save the power key status into EEprom. Turn on the LED and set it to green color. Scalar initializes. 10) In standby mode? 11) Update the lifetime of back light. 12) Check the analog port, are there any signals coming? 13) Does the scalar send out an interrupt request? 14) Wake up the scalar. 15) Are there any signals coming from analog port? 16) Display "No connection Check Signal Cable" message. And go into standby mode after the message disappears. 17) Program the scalar to be able to show the coming mode. 18) Process the OSD display. 19) Read the keyboard. Is the power key pressed? 15 DELL E173FP Service Manual 5.3 Electrical Block Diagram 5.3.1 Main Board LCD Interface (CN103) LCD Panel Scalar GmZan3-SL (Include ADC, Scalar, OSD) MCU Win Bond W78E65 (SyncMos SM5964) (U101) (U102) RGB NVRAM_SDA NVRAM_SCL OSD Control Interface (CN101) RXD TXD EEPROM M24C16 (U104) D-Sub Connector (CN100) DB12_SDA, DB15_SCL EEPROM 24C02 (U103) 16 H-sync, V-sync DELL E173FP Service Manual 5.3.2Power Block Diagram PWPC1742LGD1 Function test 1 CON205 CN102 2 R8 CCFL 1 1 2 3 4 5 6 7 8 9 10 11 12 CON206 2 R6 R9 CCFL 10 R7 10 M4 Vrms METER V Vrms METER V 1 CON207 DIM 12V 5V GND M2 GND Model name : PWPC1742LGD1 M3 ON/OFF R2 5 V R1 METER V 100 PCB NO.715L1283-1 2 R12 R4 CCFL 1 CON208 560 2 R13 CCFL 10 Vrms M6 METER V L R11 10 M5 Vrms VR1 GND R10 10K N CN901 METER V AC IN Function test step : Specification : M1 = 12V +- 0.5V , M2 = 5V +- 0.25V Step1 : 1. Adjust VR1 ( Set Vdim voltage from 0V to 5V) , then check M3 / M4/M5/M6 Vrms . 1. M3 / M4/M5/M6 = 6.5 +- 5 mV @ DIM= 5V M3 / M4 /M5/M6= 3.0 +- 5 mV @ DIM= 0V 2. M3 / M4/M5/M6= 55KHz +- 5 KHz 2. Check M3 / M4/M5/M6operating frequency. ( note 1 ) Note 1: M3 / M4/M5/M6 need to use two channel multimeter , such as FLUKE 45 , or use the oscilloscope check frequency. 17 R5 100 V M1 METER V DELL E173FP Service Manual 6. Schematic R129 100 1/16W 2 TXD 2 FB101 22 1/16W R101 100 OHM C104 0.047uF FB102 22 1/16W R104 100 OHM C106 0.047uF FB103 22 1/16W R105 100 OHM C108 0.047uF C109 C110 C111 NC NC NC R109 100 1/16W R110 100 1/16W R111 100 1/16W D106 BAV99 VGA_CON 0 1/16W 2.2K 1/16W GND NC GND R119 R120 RED- 2 GREEN- 2 BLUE- 2 2 R112 47 1/16W R114 47 1/16W VGA_CAB 2 HSY NC 2 VSY NC 2 BAT54C-GS08 GND 100 1/16W 100 1/16W D112 MLL5232B 5.6V GND 2 D110 R118 47K 1/16W R103 NC 8 7 6 5 C119 GND U103 M24C02WMN6 VCC WP SCL SDA A0 A1 A2 GND 0.1uF/16V 1 2 3 4 R102 100 1/16W R113 GND PC5V NC R117 47K 1/16W CLK_DDC DAT_DDC C118 +5V 1 C117 BLUE+ 3 GND D109 MLL5232B 5.6V MLL5232B 5.6V MLL5232B 5.6V D108 R116 2.2K 1/16W R115 D111 MLL5232B 5.6V C114 0.047uF 2 GREEN+2 +5V VSI GND C113 0.047uF GND FB104 D107 C112 0.047uF RED+ 1 3 2 3 D105 BAV99 1 2 GND D101 BAV99 2 D104 MLL5232B 5.6V GND HSI RXD D103 100 1/16W GND 3 VGA 1 17 15 16 CLK_DDC R128 R108 75 1/16W 14 R107 75 1/16W 13 R106 75 1/16W HSI GNDGND RIN gndR GIN gndG BIN gndB 1 6 2 7 3 8 4 9 5 10 12 VSI PC5V PC5V DAT_DDC R132 2.7K 1/16W R131 2.7K 1/16W GND GNDGND MLL5232B 5.6V MLL5232B 5.6V CN100 11 D102 6.1 Main Board R100 100 1/16W 100 1/16W R156 47K 1/16W DDC_/WP 2 GND Title DDC_SCL 2 Size A Input Connector DDC_SDA 2 18 Date: Document Number Rev C Zan3 SL MAIN BOARD Friday , February 13, 2004 Sheet 1 of 5 DELL E173FP Service Manual +1.8V_VDD C126 C127 L102 120 OHM C128 C129 22uF/16V 0.1uF/16V 0.1uF/16V 0.1uF/16V 0.1uF/16V 0.1uF/16V 0.1uF/16V C131 C132 C133 C134 U102 C135 3.3V_LAVDD 0.1uF/16V 0.1uF/16V 0.1uF/16V 0.1uF/16V 0.1uF/16V 0.1uF/16V Clos e to re s pe ctive pow e r Pins GND Clos e to re s pe ctive pow e r Pins GND 3.3V_AVDD C130 + 69 79 89 3.3V_AVDD 1.8V_AVDD 83.4m A L103 120 OHM C136 22uF/16V 1.8V_AVDD C137 + 84 82 42.2m A C138 Clos e to re s pe ctive pow e r Pins 0.1uF/16V 0.1uF/16V L104 120 OHM C140 22uF/16V 3.3V_PVDD GND 8.1m A 3.3V_LAVDD L106 120 OHM 6.4m A C141 + C142 81 72 76 80 0.1uF/16V 0.1uF/16V GND 83 86 C139 L105 120 OHM 0.1uF/16V C143 AVDD_ADC_3.3 AVDD_ADC_3.3 AVDD_RPLL_3.3 0.1uF/16V 87 R121 22 1/16W 88 TCLK FOR ZAN3SL AVSS_LV VSS_OUT_LV VSS_OUT_LV GND_ADC AGND_ADC AGND_ADC AGND_ADC +5V +5V 91 R124-RESET FUNCTION VSS_RPLL AVSS_RPLL XTAL UDART_DI UDART_DO RXD TXD X101 14.318MHz G-PROBE TCLK GND +5V C147 10pF GND C148 10pF GND +5V C150 A0 A1 A2 VSS VCC WP SCK SI 8 7 6 5 AD7/P0.7 AD6/P0.6 AD5/P0.5 AD4/P0.4 AD3/P0.3 AD2/P0.2 AD1/P0.1 AD0/P0.0 XTAL2 XTAL1 EA#/VPP VCC 22 VSS P3.6/WR# P3.7/RD#/A16 ALE/PROG# P4.1 P4.0 P4.3/INT2 P4.2 100 1/16W /WP 100 1/16W NVRAM_SCL 100 1/16W NVRAM_SDA R145 NC 3 3 3 3 17 18 19 20 21 22 23 24 25 26 LVDS_O9 LVDS_O8 LVDS_O7 LVDS_O6 LVDS_O5 LVDS_O4 LVDS_O3 LVDS_O2 LVDS_O1 LVDS_O0 LVDS_E[0..9] TCLK CH3P_LV_O/G2 CH3N_LV_O/G3 CLKP_LV_O/G4 CLKN_LV_O/G5 CH2P_LV_O/G6 CH2N_LV_O/G7 CH1P_LV_O/B0 CH1N_LV_O/B1 CH0P_LV_O/B2 CH0N_LV_O/B3 RED+ REDGREEN+ GREENBLUE+ BLUE- LVDS_O[0..9] HSY NC VSY NC SOG_MCSS PPWR PBIAS 18 19 33 34 23 12 1 WRn RDn ALE R130 R148 PPWR PBIAS 30 29 PPWR PBIAS LVDS_E[0..9] 4 LVDS_O[0..9] 4 5 5 DDC_SCL DDC_SDA RESETn C145 0.1uF/16V 46 DDC_SCL 97 DDC_SDA 98 49 61 66 GPIO0/PWM0 GPIO1/PWM1 GPIO2/DHS GPIO3/DVS GPIO4/DEN GPIO5/DCLK GPIO10/IRQn DDC_SCL DDC_SDA GPIO6/B7 GPIO7/B4 GPIO8/B6 GPIO9/B5 GPIO13/AD7 GPIO12/AD6 GPIO11/AD5 HFS/AD4 HDATA3/AD3 HDATA2/AD2 HDATA1/AD1 HDATA0/AD0 52 53 BRIGHTNESS 5 54 55 56 57 58 59 60 50 LED_O LED_G 3 3 R173 NC VBUFS_RPLL VCO_LV +5V A15 4.7K 1/16W RDn WRn R136 ALE R147 R138 NC NC NC RESET_OUT GND IRQn GND 1 1 90 38 39 40 41 42 43 44 45 PLCC44 - SOCKET-87L202-44 +5V Philips P89C51RD2 Winbond W78E65P-PLCC44 SyncMOS SM2965 WINBOND W78E65P-40-56L1125-137-X VGA_CAB 1 36 37 38 39 40 41 42 43 SOCKET GND R137 R139 R141 P3.0/RXD P3.1/TXD P3.2/INT0# P3.3/INT1# P3.4/T0 P3.5/T1 R124 NC VGA_CAB R125 100 1/16W KEY _MENU KEY _MENU KEY _RIGHT KEY _RIGHT KEY _LEFT KEY _LEFT KEY _ONOFF KEY _ONOFF A14 A15 R140 M24C16-MN6T GND 4.7K 1/16W 1 2 3 4 4.7K 1/16W 4.7K 1/16W 0.1uF/16V 20 21 A8/P2.0 A9/P2.1 A10/P2.2 A11/P2.3 A12/P2.4 A13/P2.5 A14/P2.6 A15/P2.7 PSEN# C149 R133 R134 R135 U104 11 13 14 15 16 17 35 44 0.1uF/16V LVDS_E9 LVDS_E8 LVDS_E7 LVDS_E6 LVDS_E5 LVDS_E4 LVDS_E3 LVDS_E2 LVDS_E1 LVDS_E0 A14 4.7K 1/16W NC R142 R146 NC 0 1/16W 37 36 35 34 RDn WRn HCLK/ALE MEM_REG 0 1/16W 62 63 GND A14 => MEM_REG(ZAN3SL) A15 => HCLK(ZAN3SL) NC STI_TM1 STI_TM2 85 2 CRVSS CRVSS CRVSS CRVSS CRVSS CRVSS 1 1 UDART_DO UDART_DI 5 6 7 8 9 10 11 12 13 14 32 48 64 68 93 100 1 2 3 4 P1.0/T2 P1.1/T2EX P1.2/ECI P1.3/CEX0 P1.4/CEX1 P1.5/CEX2 P1.6/CEX3/WAIT# P1.7/CEX4/A17/W RST 24 25 26 27 28 29 30 31 32 Hardwave ISP function C151 NC CN102 2 3 4 5 6 7 8 9 10 /WP PPWR R151 NC PBIAS R152 NC R127 4.7K 1/16W U101 100 1/16W 1 DDC_/WP 3 15 27 +5V R143 4.7K +5V R150 NC 95 96 73 R122 4.7K 1/16W R126 R153 NC OPTIONAL FOR DEBUGGING PURPOSES ONLY HSY NC VSY NC R144 4.7K +5V 1 1 77 78 74 75 70 71 100 1/16W +5V 4.7K 1/16W R123 RED+ REDGREEN+ GREENBLUE+ BLUE- 4 16 28 GND CH3P_LV_E/R0 CH3N_LV_E/R1 CLKP_LV_E/R2 CLKN_LV_E/R3 CH2P_LV_E/R4 CH2N_LV_E/R5 CH1P_LV_E/R6 CH1N_LV_E/R7 CH0P_LV_E/G0 CH0N_LV_E/G1 GND 1 1 1 1 1 1 1 VDD_RPLL_1.8 VDD_ADC_1.8 GND GND AVDD_LV_3.3 VDD_OUT_LV_3.3 VDD_OUT_LV_3.3 VDD_OUT_LV_3.3 C144 + 22uF/16V 3.3V_DVDD 31 47 65 67 92 99 C125 CVDD_1.8 CVDD_1.8 CVDD_1.8 CVDD_1.8 CVDD_1.8 CVDD_1.8 + C124 33 51 94 C123 1.8V_DVDD 1.8V_DVDD 139m A 58.27m A L101 120 OHM C122 22uF/16V 3.3V_DVDD 3.3V_PVDD 3.3V_DVDD RVDD_3.3 RVDD_3.3 RVDD_3.3 +3.3V_VDD Re fe r BOOTSTRAP OPTIONS GND GMZAN3 SL QFP-100 GND GND Title ZAN3 SL & MCU Size C Date: 19 Document Number Rev C Zan3 SL MAIN BOARD Friday , February 13, 2004 Sheet 2 of 5 DELL E173FP Service Manual 8 7 6 5 +5V 2 LED_G 1 2 3 4 2 LED_O 1 Q101 PMBS3904 4.7K 1/16W 2 R155 LED_O 1 R154 LED_G 3 RP103 4.7K 1/16W 3 +5V +5V Q102 PMBS3904 CN101 2 4.7K 1/16W LED_ORANGE 2 KEY _MENU 2 KEY _RIGHT 2 KEY _LEFT 2 KEY _ONOFF KEY _MENU KEY _RIGHT KEY _LEFT KEY _ONOFF R157 R158 R159 R160 C154 C156 C155 0.001uF0.001uF 0.001uF GND GND GND ENTER RIGHT LEFT POWER 220 1/16W 220 1/16W 220 1/16W 220 1/16W C157 0.001uF GND LED_GREEN GND C152 0.001uF GND 8 7 6 5 4 3 2 1 To k e yboard CONN C153 0.001uF GND Title KEYS CONNECTION Size A Date: 20 Document Number Rev C Zan3 SL MAIN BOARD Friday , February 13, 2004 Sheet 3 of 5 DELL E173FP Service Manual LVDS_O[0..9] LVDS_O0 LVDS_O1 LVDS_O2 LVDS_O3 LVDS_O4 LVDS_O5 LVDS_O6 LVDS_O7 LVDS_O8 LVDS_O9 2 CN103 LVDS_O0 LVDS_O2 LVDS_O4 LVDS_O6 LVDS_O8 LVDS_E0 LVDS_E2 LVDS_E4 LVDS_E6 LVDS_E8 RXO0RXO1RXO2RXOCRXO3RXE0RXE1RXE2RXECRXE3- 1 3 5 7 9 11 13 15 17 19 21 23 LVDS_E[0..9] LVDS_E0 LVDS_E1 LVDS_E2 LVDS_E3 LVDS_E4 LVDS_E5 LVDS_E6 LVDS_E7 LVDS_E8 LVDS_E9 2 4 6 8 10 12 14 16 18 20 22 24 RXO0+ RXO1+ RXO2+ RXOC+ RXO3+ RXE0+ RXE1+ RXE2+ RXEC+ RXE3+ LVDS_O1 LVDS_O3 LVDS_O5 LVDS_O7 LVDS_O9 LVDS_E1 LVDS_E3 LVDS_E5 LVDS_E7 LVDS_E9 CONN24A +VLCD 15.4mA 2 GND + C158 100uF/16V GND R172 C159 0.1uF/16V 330 1/8W FOR LAYOUT 100uF/16V GND Title PANEL INTERFACE Size A Date: 21 Document Number Rev C Zan3 SL MAIN BOARD Friday , February 13, 2004 Sheet 4 of 5 DELL E173FP Service Manual CN104 1 2 3 4 5 6 BLON/OFF DIMMING R162 4.7K 1/16W 2 PBIAS +5V +3.3V_VDD FB105 120 OHM TO263 C163 0.1uF/16V GND CONN + C162 100uF/16V +5V U105 AIC1084-33M 3 VIN VOUT C164 0.1uF/16V GND D113 NC R164 1K 1/16W + C165 47uF/16V 147m A ADJ + C168 0.1uF/16V 0.1uF/16V GND BRIGHTNESS Brightness 1 C167 2 C166 47uF/16V GND R165 2 +5V GND GND GND GND 1K 1/16W C169 2.2uF + GND +VLCD +5V R168 4.7K 1/16W R167 NC U106 3 Q104 AO3401 1 + 0.1uF/16V 3D GND 1 G 3 R170 NC VI VO C173 2 Q105 PMBS3904 C175 R169 0 1/16W C172 22uF/16V GND 204m A 2 C171 47uF/16V 0.1uF/16V 1 PPWR 2 2 3 1 R171 100K 1/16W +1.8V_VDD SOT-223 +3.3V_VDD GND +5V + C174 0.1uF/16V 0.8A-m ax GND GND GND GND AO3401 2 S Title POWER Size A Date: 22 Document Number Rev C Zan3 SL MAIN BOARD Friday , February 13, 2004 Sheet 5 of 5 DELL E173FP Service Manual 6.2 Internal Power Board C0N102 GND GND 5V 5V GND GND 12V 12V DIM GND ON/OFF GND 12 11 10 9 8 7 6 5 4 3 2 1 5V 12V DIM ON/OFF GND R920 47 1/2W C920 0.001uF/500V T901 33A8009-12G-H D910 4 1 O + DB901 2KBP06M 1 R906 1M 1/4W 3 + C904 120uF/400V R904 1M 1/4W C905 0.0015uF/2KV - R905 1M 1/4W R903 100K 2W R921 47 1/2W O 7,8 7,8 1 C907 0.1uF 4 C906 22uF + D902 PS102R R908 5.1 1/4W 4O C930 1000P/50V C926 0.1uF L904 5V D911 10A/100V 5 L902 73L-174-26-T C924 470uF/16V ZD904 SML4736 2 3 12V + C921 0.001uF/500V UF4007 3 2 L903 20A/100V + C922 1000uF/16V D901 R907 1M 1/4W 9 + C923 1000uF/16V 10,11 + C925 470uF/16V C931 1000P/50V C927 0.1uF 7 IC901 SG6841 3 C903 0.47uF/250V 8 4 R915 10 1/4W Q903 FQPF7N80C,STP8NK80ZFP SG6841 1 5 6 2 R914 24K 1/4W FB901 BEAD C911 N.C 1/6W C912 0.0047uF/250V R929 100 1/4W R916 10K 1/4W R913 10K 1/4W F901 FUSE C901 C902 0.001uF/250V 0.001uF/250V 4 NR901 NTCR IC902 PC123FY82 4P R909 4.7K 1/4W 3 t ZD902 HZ12B2 R917 0.39 2W C910 0.001uF ZD903 HZ5C1 1 R902 1M 1/4W R928 1K 1/4W R925 1K 1/4W 2 R901 1M 1/4W D903 1N4148 ZD901 MTEJ20B R912 100 1/4W C908 0.1uF R910 4.7K 1/4W C929 0.1uF R922 33K 1/4W R927 0 1/4W R923 3.6K 1/4W R926 1K 1/4W Q901 2PA733P IC903 HTL431 3 Q902 2PC945P 2 1 C909 0.1uF C928 0.01uF R911 4.7K 1/4W R924 2.4K 1/4W CN901 AOC (Top Victory) Electronics Co., Ltd. Title 23 1.POWER 12V&5V OUTPUT Size Document Number Date: Tuesday, March 16, 2004 Rev PWPC1742LGD1(715L-1283-1) Sheet A 2 of 2 DELL E173FP Service Manual Q203 SI4431 OR AO4411 TP1 L201 150UH L205 +12V 1 2 3 4 JUMP Q202 C202 Q201 + C201 DTA144WKA 0.1U/25V 150U/25V C230 1000P/50V DTC144WKA R212 3.9K R224 R225 1K 1K 2 6 L206 JUMP 3.9K R208 4.7K 3 1 7 80AL15T-7-YS R222 15K 1 R232 1K D205 RLS4148 L203 2 1 D209 RLS4148 4 3 73L174-30-YS 2SC5706 C209 4.7U/16V R205 68K C205 2 1 Q210 R218 470 1 HVL OPEN 33L8021-2D R214 Q207 SST3906 CON203 TP3 9 TP4 HVL 0.18U/160V 2SC5706 D201 SMAL240 OR SR24 PT201 3,4 1 R220 12K R210 12K R207 OPEN C207 5 3 R202 5.1K 2 33L8021-2D C213 Q209 0.1U/25V Q205 SST3904 1 OPEN C227 C211 1U/25V NO/OFF CON201 R226 R227 1K 1K D203 11B R216 220 C204 C226 1 HVO 8 7 6 5 1 4A/63V 2 F201 C224 2 1U/25V R234 620 OPEN D207 R240 RLS4148 0.1U/25V C221 C219 51K R238 1 2 3 4 8 7 6 5 + C223 C231 150U/25V 1000P/50V R213 3.9K R217 220 C212 1U/25V Q211 1 R223 15K R219 1 HVL 2 7 R233 1K 33L8021-2D D206 RLS4148 1 L204 4 1 470 D210 RLS4148 2SC5706 R235 620 D208 R241 AOC (Top Victory) Electronics Co., Ltd. is power GND Title 2. FOR 17"&15" 4 LAMPS INVERTER Document Number PWPC1742LGD1(715L-1283-1) Sheet 2 Rev A of is signal GND 2 24 C222 C225 RLS4148 C220 51K R239 0.47U/25V 2 3 73L-174-30-YS 2 0.1U/25V Tuesday, March 16, 2004 CON204 OPEN Q212 C206 Date: 33L8021-2D 80AL15T-7-YS C203 Size 2 TP6 C229 9 3,4 1 Q208 SST3906 3.9K PT202 OPEN 2 6 3 R215 R211 12K 0.18U/160V 2SC5706 Q206 SST3904 R209 4.7K R203 5.1K 1U/25V 1 D202 R221 12K SMAL240 OR SR24 1 1 HVO 5 C216 CON202 TP2 3 R206 68K R230 R231 1K 1K D204 11B 1U/25V TP5 HVL C228 R228 R229 1K 1K 2 1 2 3 4 5 6 7 8 C210 R236 510 L202 150UH C208 330P/50V R204 10K 1U/25V 12K 1 16 15 14 13 12 11 10 9 Q204 SI4431 OR AO4411 REF CT SCP RT 1IN+ 2IN+ 1IN2IN1FBK 2FBK 1DTC 2DTC 1OUT 2OUT GND Vcc TL1451ACDR R201 24K U201 DIM 0.47U/25V OPEN R237 510 12K 1U/25V DELL E173FP Service Manual 7. PCB Layout 7.1 Main Board 25 DELL E173FP Service Manual 7.2 Inverter/Power Board 26 DELL E173FP Service Manual 27 DELL E173FP Service Manual 7.3 Keypad Board 8. Maintainability 8.1 Equipments and Tools Requirement ¾ Voltage meter. ¾ Oscilloscope. ¾ Pattern Generator. ¾ DDC Tool with a IBM Compatible Computer. ¾ Alignment Tool. ¾ LCD Color Analyzer. ¾ Service Manual. ¾ User Manual. 28 DELL E173FP Service Manual 8.2 Trouble Shooting 8.2.1 Main Board 1) No display Check Power board, is there DC level output?. Check Measured CN104 pin 5 = 5 V? U105 pin3=5V, P105 pin2=3.3V? No DC Level Is there any Measured U101 pin44=5V? shortage or cold solder or PCB trace is disconnected? Measured U105 pin 2= 3.3V? Check Correspondent component Yes. There have OSD show Yes, all DC level exist Disconnected the Signal cable (Loose the Connected the Signal cable again, Signal cable), Is the screen show Block Check LED status. LED Green WRGB color bars? No, nothing is show Led Orange Connected the Signal cable again, Check Power switch is in Replace U102 Power-on status, and check if Scalar IC Power switch had been stuck? Check LED status. Led orange OK, Keyboard no stuck Led Green Check the Wire-Harness from CN101 Check Correspondent component short/open Measured RGB (R112, R114) H, V Input at U102 pin 95, 96, was there have signal? Protection Diode and NG Signal cable bad? OK, Wire tight enough Check Panel-Power Circuit Block OK, input Normal OK, Panel Power Check U200 Data-output Block Measured Crystal X101 OK, U102 data OK OK, clock normal Replace Inverter board and Check Inverter control relative Replace U102 (GMZan3SL) Re-do White balance OK Note: 1. If Replace “MAIN-BOARD”, Please re-do “DDC-content” programmed & “WHITE-Balance”. 2. If Replace “Inverter Board” only, Please re-do “WHITE-Balance” 29 DELL E173FP Service Manual 2) PANEL-POWER CIRCUIT Check the PPWR panel power relative circuit, NG Check R172 should have response from 0V to 5V Q105, Q104 In normal operation, when LED =green, When we switch the power switch from on to off R172 should =5 v, If PPWR no-response when the power switch Turn on and turn off, replace the U102(GMZan3-SL) OK, R172 have response NG, no Check U202 pin 4, 16, 28=3.3V? Measured the Q104 pin 3= 5 V? Yes OK Replace Q104 ( N-mos, AO3401) OK 3) INVERTER CONTROL RELATIVE CIRCUIT Measured the inverter connector CN104 NG Pin1 on/off control=3.3V (on) Check the Bklt-On relative circuit, R162, In normal operation, when LED =green, R162 Bklt-On should =3.3V, Pin2 PWM signal control dim 0V-5V If Bklt-On no-response when the power switch turn on-off, Replace U102 GMZan3-SL NG, still no screen Replace Inverter board to new-one, NG Check NO SCREEN APPEAR block and Check the screen is normal?? OK 30 DELL E173FP Service Manual 4) U102-DATA OUTPUT NG, no transition Measured U102 DVS, DHS Is the waveform ok? DCLK around 48 MHZ, DVS=60.09Hz, DHS Replace GMZan3 –SL (U102) or around 31 KHz? (Refer to input replace MAINBOARD. signal=640x480@60 Hz 31k, and LED is Green) OK If Main Board being replaced please do the DDC – content reprogrammed and re-do white balance adjustment Check U102 GMZan3-XL Signal output TX1+, TX1-, TX2+, NG TX2-, TX3+, TX3-, Is the waveform ok? OK OK 31 DELL E173FP Service Manual 8.2.2 Power/Inverter Board 1.) No power Check to CN102 Pin9 and pin10 = 5V NG OK Check Interface board Check AC line volt 120V or 220V NG Change F901 , check BD901,Q903,IC901 OK Check the voltage of C904(+) NG Check bridge rectified circuit cFailure point OK Check start voltage for the pin3 of IC901 NG Change IC901 Repeating the start voltage Check the auxiliary voltage is smaller than 20V OK NG 1) Check IC902, IC903 2) Check Q901,Q902…OVP circuit Check R919, D910,D911,D912,D913, ZD904 32 DELL E173FP Service Manual 2.) W / LED, No Backlight Check C201 (+) Change F902 NG Check D201/Q209/Q210 or OK Check ON/OFF signal NG Check Interface board Check U201 pin9=12V voltage of C905(+) NG Change Q201 or Q202 OK Check the pin1 of U201 have sawtooth wave NG Change U201 OK Check D201(-),D202(-) have the output of square wave at short time. NG Check Q205/Q207/Q203/D201 or Q206/Q208/Q204/D202 OK Check the resonant wave of pin2 & pin5 for PT201/PT202 NG Check Q209/Q210/C213 or Q211/Q212/C214 Check the output of NG Change PT201or PT202 Check connector & lamp 33 DELL E173FP Service Manual 8.2.3 Keypad Board OSD is unstable or not working Is Keypad Board connecting normally? N Connect Keypad Board Y N Is Button Switch normally? Replace Button Y N Is Keypad Board Normally? Y Check Main Board 34 Replace Keypad DELL E173FP Service Manual 9. White-Balance, Luminance adjustment Approximately 2 Hours should be allowed for warm up before proceeding white balance adjustment. Before started adjust white balance, please setting the Chroma-7120 MEM. Channel 1 to 65000K colors, MEM. Channel 3 to 93000K colors, MEM. Channel 1 to 57000K (our 9300 parameter is x = 296 ±10, y = 311 ±10, Y = 180 ±10 cd/m2, 6500 parameter is x = 313 ±10, y = 329 ±10, Y = 180 ±10 cd/m2,and 5700 parameter is x = 328 ±10, y = 344 ±10, Y = 180 ±10 cd/m2) How to setting MEM.channel you can reference to chroma 7120 user guide or simple use “ SC” key and “ NEXT” key to modify xyY value and use “ID” key to modify the TEXT description Following is the procedure to do white-balance adjust Press MENU and AUTO-ADJUST button during press Power button will activate the factory mode, Gain adjustment: Move cursor to “-Factory Setting-” and press MENU key to enter this sub-menu; Move cursor to “ Factory” and press MENU key; Move cursor to “ Auto Level” and press MENU key to adjust Gain and Offset automatically; a. Adjust sRGB (65000K) color-temperature 1 2 3 Switch the chroma-7120 to RGB-mode (with press “MODE” button) Switch the MEM.channel to Channel 01 (with up or down arrow on chroma 7120) The LCD-indicator on chroma 7120 will show x = 313 ±10, y = 329 ±10, Y = 180 ±10 cd/m2 4 5 6 7 8 In sRGB sub-menu, adjust C to 192, adjust L to 230 ; Adjust the RED on OSD window until chroma 7120 indicator reached the value R=100 Adjust the GREEN on OSD, until chroma 7120 indicator reached G=100 Adjust the BLUE on OSD, until chroma 7120 indicator reached B=100 repeat above procedure ( item 5,6,7) until chroma 7120 RGB value meet the tolerance =100±2 b. Adjust Color1 (93000K) color-temperature 9 Switch the chroma-7120 to RGB-mode (with press “MODE” button) 10 Switch the MEM.channel to Channel 03 ( with up or down arrow on chroma 7120 ) 11 The LCD-indicator on chroma 7120 will show x = 296 ±10, y = 311 ±10, Y = 180 ±10 cd/m2 12 13 14 15 16 In Color1 sub-menu, adjust C to 192, adjust L to 230 ; Adjust the RED on OSD window until chroma 7120 indicator reached the value Adjust the GREEN on OSD, until chroma 7120 indicator reached G=100 Adjust the BLUE on OSD, until chroma 7120 indicator reached B=100 repeat above procedure ( item 5,6,7) until chroma 7120 RGB value meet the tolerance =100±2 35 R=100 DELL E173FP Service Manual c. Adjust Color2 (57000K) color-temperature 17 Switch the chroma-7120 to RGB-mode (with press “MODE” button) 18 Switch the MEM.channel to Channel 03 (with up or down arrow on chroma 7120) 19 The LCD-indicator on chroma 7120 will show x = 328 ±10, y = 344 ±10, Y = 180 ±10 cd/m2 20 21 22 23 24 25 In Color2 sub-menu, adjust C to 192, adjust L to 230 ; Adjust the RED on OSD window until chroma 7120 indicator reached the value R=100 Adjust the GREEN on OSD, until chroma 7120 indicator reached G=100 Adjust the BLUE on OSD, until chroma 7120 indicator reached B=100 repeat above procedure ( item 5,6,7) until chroma 7120 RGB value meet the tolerance =100±2 Move cursor to “ Exit/Save” sub-menu and press MENU key to save adjust value and exit; Turn the POWER-button off to on to quit from factory mode. 36 DELL E173FP Service Manual 10. EDIT Content D-SUB Connector (Analog) 00 01 02 03 04 05 06 07 08 09 0: 00 FF FF FF FF FF FF 00 10 AC 16: 34 0D 01 03 68 22 1B 78 2A 2D 32: 11 50 54 A5 4B 00 71 4F 81 80 48: 01 01 01 01 01 01 30 2A 00 98 64: 13 00 78 2D 11 00 00 1E 00 00 80: 38 30 33 39 43 30 30 31 43 0A 96: 4C 1F 50 0E 00 0A 20 20 20 20 112: 00 44 45 4C 4C 20 45 31 37 33 A 0B 90 01 51 00 00 20 46 B A0 A4 01 00 FF 00 20 50 C 43 57 01 2A 00 00 00 63 D 31 4A 01 40 36 FD 00 20 E 30 9C 01 30 34 00 00 00 F 30 25 01 70 31 38 FC 49 Note: Byte 0C, 0D, 0E, 0F means Serial No. Byte 10, 11 means Manufacture Time. Byte 7F means checksum 37 DELL E173FP Service Manual 11. ISP (In System Program) User Manual 11.1. Connect ISP Writer preparation action: Connect RXD and TXD of PC to RXD (P3.0) and TXD (P3.1) of CPU through RS-232. a. There are two ways to entering Reboot Mode. The settings for Reboot Mode is as follow: ☆Both P2.6、P2.7 are LOW and RESET pin is HI. ☆P4.3 is LOW and RESET pin is HI . 11.2. To Use ISP WRITER Press the “–“ key at front bezel and plug the AC power cord in, then the MCU enter ISP mode; a. You will enter the window as follow after executing the ispwriter.exe file. 38 DELL E173FP Service Manual b. Click the “Select Chip” button, and choose the type you’re going to program. Choose “W78E65” and click “OK” button 39 DELL E173FP Service Manual c. Click the “Select Bank0” button and selecting a file which a binary Format required. Choose bin file and open it 40 DELL E173FP Service Manual d. Select the communication Setting: Port Name e. Click the “ConNect” button. These buttons will be enable. 41 DELL E173FP Service Manual f. Click “Program all” to start programming. 11.3. Executing ISP a. Click “Program All” button that will execute erase and program and verify. Then you can get the window as follow, and click “OK” to complete ISP process. b. Complete the ISP process, click “eXit LD” button to reset monitor. 42 DELL E173FP Service Manual 12. Bill Of Material List Location Part Number Description Qty. Unit CBPC780KGLDD CONVERSION BOARD 1 PCS KEPC780KED1 KEY BOARD 1 PCS PWPC1742LGD1 POWER BOARD 1 PCS 11L6036 1 SPACER SUPPORT SCC-24 1 PCS 15L8054 2 MAIN FRAME 1 PCS 23L3178700 1A LOGO 1 PCS 33L4669 GV C POWER BUTTON 1 PCS 33L4670 GV T KEY PAD 1 PCS 34L1367AY2 T BEZEL 1 PCS 34L1368 Y2 T REAR COVER 1 PCS 40L 152509 RECYCLE LABEL 0 PCS 40L 152512 RECYCLE LABEL 0 PCS HI-POT 1 PCS 40L 190700 1A6310 ID LABEL 1 PCS 40L 459700 1A6444 DELL S/N LABEL 1 PCS 40L 581 267046036 SHIPPING LABEL 0.01 PCS 40L 581700 3A6444 CARTON LABEL 1 PCS 41L7800700 2A QSG 1 PCS 44L3733 1 EPS 1 PCS 44L3733 2 EPS 1 PCS 44L3733700 1A CARTON 1 PCS 44L6000 SPACE PAPER 40L 154501 16444 4 6B 45L 77512 45L 88607DE6 52L F6863 1186 BARCODE RIBBOR 0.0077 PCS 18 MM PE BAG FOR MONITOR 1 PCS SMALL TAPE 8 CM 1 PCS 52L6020 2DE4 FILM PROTECT 52L6022 1500 SMALL TAPE 12 CM 70L1700700 1A CD MANUAL 1 PCS 85L 672 1 SHIELD 1 PCS 85L 673 1 SHIELD-INVERTER 1 PCS 89L1738GAA 16 SIGNAL CABLE 1 PCS 89L401A18NHRA POWER CORD 1 PCS 95L8018 30529 WIRE HARNESS 1 PCS M1L1140 6128 SCREW 4X6 1 PCS M1L1430 6128 SCREW M3X6 4 PCS M1L1430 6128 SCREW M3X6 5 PCS M1L1430 6128 SCREW M3X6 3 PCS 43 DELL E173FP Service Manual -------- M1L2640 10225 SCREW 4 PCS Q1L 330 SCREW 3X8mm 3 PCS 705L 780 87 DL CN901 ASS'Y 1 PCS 705L780KB34 79 BACK COVER ASS'Y 1 PCS 750LLG70E01 LVDS PANEL LM170E01-A5N 1 PCS 44L3231511 旧筿獁粗 2 PCS 44L3231512 旧筿獁粗 3 PCS 3 ------------------- -------------------------- -------- ----- PARENT NO: -------- 8 47 CBPC780KGLDD CONVERSION BOARD ------------------- -------------------------- -------- ----AIC780KSLDD MAIN BOARD 1 PCS CN101 33L3802 8H WAFER 8P RIGHT ANGLE PI 1 PCS CN104 33L8013 6 H 6P PLUG R/A 1 PCS CN103 33L8027 24 H CONN W TO B12P*2 P*2.0 1 PCS U101A 56L1125137LD3 W78E65P-40 BY WINBOND 1 PCS C158 67L309V101 3 100UF 16V 1 PCS C162 67L309V101 3 100UF 16V 1 PCS C122 67L309V220 3 22UF +-20% 16V 1 PCS C129 67L309V220 3 22UF +-20% 16V 1 PCS C136 67L309V220 3 22UF +-20% 16V 1 PCS C140 67L309V220 3 22UF +-20% 16V 1 PCS C143 67L309V220 3 22UF +-20% 16V 1 PCS C172 67L309V220 3 22UF +-20% 16V 1 PCS C169 67L309V229 7 2.2UF +-20% 50V 1 PCS C165 67L309V470 3 47UF 16V 85C 1 PCS C166 67L309V470 3 47UF 16V 85C 1 PCS C171 67L309V470 3 47UF 16V 85C 1 PCS CN100 88L 35315F H D-SUB 15PIN 1 PCS X101 93L CRYSTAL 14.318MHzHC-49U 1 PCS -------- ------------------- -------------------------- -------- ----- PARENT NO: 22 53 AIC780KSLDD MAIN BOARD -------- ------------------- -------------------------- -------- ----- U102 56L 562 58 GMZAN3/SL (AC) 1 PCS U106 56L 563 27 AIC1117A-18CY SOT-223 1 PCS U106 56L 56327A AP1117E18A SOT223-3L 0 PCS U105 56L 585 AIC1117-33CY 1 PCS U105 56L 585 4A AP1117E33A 0 PCS U103 56L1133 34 M24C02-WMN6T SMT 1 PCS U104 56L1133 56 M24C16-WMN6T/W SO-8 1 PCS Q101 57L 417 PMBS3904/PHILIPS-SMT(04 1 PCS 4 4 44 DELL E173FP Service Manual Q102 57L 417 4 PMBS3904/PHILIPS-SMT(04 1 PCS Q105 57L 417 4 PMBS3904/PHILIPS-SMT(04 1 PCS Q104 57L 763 1 A03401 SOT23 BY AOS(A1) 1 PCS Q104 57L 763 1A AP2305N 0 PCS RP103 61L 125472 CHIP AR 8P4R 4.7K OHM+- 1 PCS FB104 61L0603000 CHIPR 0OHM +-5% 1/10W 1 PCS R142 61L0603000 CHIPR 0OHM +-5% 1/10W 1 PCS R146 61L0603000 CHIPR 0OHM +-5% 1/10W 1 PCS R169 61L0603000 CHIPR 0OHM +-5% 1/10W 1 PCS R102 61L0603101 CHIPR 100 OHM +-5% 1/10 1 PCS R109 61L0603101 CHIPR 100 OHM +-5% 1/10 1 PCS R110 61L0603101 CHIPR 100 OHM +-5% 1/10 1 PCS R111 61L0603101 CHIPR 100 OHM +-5% 1/10 1 PCS R119 61L0603101 CHIPR 100 OHM +-5% 1/10 1 PCS R120 61L0603101 CHIPR 100 OHM +-5% 1/10 1 PCS R125 61L0603101 CHIPR 100 OHM +-5% 1/10 1 PCS R126 61L0603101 CHIPR 100 OHM +-5% 1/10 1 PCS R128 61L0603101 CHIPR 100 OHM +-5% 1/10 1 PCS R129 61L0603101 CHIPR 100 OHM +-5% 1/10 1 PCS R130 61L0603101 CHIPR 100 OHM +-5% 1/10 1 PCS R137 61L0603101 CHIPR 100 OHM +-5% 1/10 1 PCS R139 61L0603101 CHIPR 100 OHM +-5% 1/10 1 PCS R141 61L0603101 CHIPR 100 OHM +-5% 1/10 1 PCS R164 61L0603102 CHIPR 1K OHM +-5% 1/10W 1 PCS R165 61L0603102 CHIPR 1K OHM +-5% 1/10W 1 PCS R171 61L0603104 CHIPR 100K OHM +-5% 1/1 1 PCS FB101 61L0603220 CHIPR 22 OHM+-5% 1/10W 1 PCS FB102 61L0603220 CHIPR 22 OHM+-5% 1/10W 1 PCS FB103 61L0603220 CHIPR 22 OHM+-5% 1/10W 1 PCS R121 61L0603220 CHIPR 22 OHM+-5% 1/10W 1 PCS R157 61L0603221 CHIPR 220 OHM+-5% 1/10W 1 PCS R158 61L0603221 CHIPR 220 OHM+-5% 1/10W 1 PCS R159 61L0603221 CHIPR 220 OHM+-5% 1/10W 1 PCS R160 61L0603221 CHIPR 220 OHM+-5% 1/10W 1 PCS R115 61L0603222 CHIPR 2.2K OHM+-5% 1/10 1 PCS R116 61L0603222 CHIPR 2.2K OHM+-5% 1/10 1 PCS R131 61L0603272 CHIP 2.7K OHM 1/10W 1 PCS R132 61L0603272 CHIP 2.7K OHM 1/10W 1 PCS R112 61L0603470 CHIPR 47 OHM +-5% 1/10W 1 PCS R114 61L0603470 CHIPR 47 OHM +-5% 1/10W 1 PCS 8 45 DELL E173FP Service Manual R122 61L0603472 CHIPR 4.7K OHM +-5% 1/1 1 PCS R123 61L0603472 CHIPR 4.7K OHM +-5% 1/1 1 PCS R127 61L0603472 CHIPR 4.7K OHM +-5% 1/1 1 PCS R133 61L0603472 CHIPR 4.7K OHM +-5% 1/1 1 PCS R134 61L0603472 CHIPR 4.7K OHM +-5% 1/1 1 PCS R135 61L0603472 CHIPR 4.7K OHM +-5% 1/1 1 PCS R143 61L0603472 CHIPR 4.7K OHM +-5% 1/1 1 PCS R144 61L0603472 CHIPR 4.7K OHM +-5% 1/1 1 PCS R147 61L0603472 CHIPR 4.7K OHM +-5% 1/1 1 PCS R148 61L0603472 CHIPR 4.7K OHM +-5% 1/1 1 PCS R154 61L0603472 CHIPR 4.7K OHM +-5% 1/1 1 PCS R155 61L0603472 CHIPR 4.7K OHM +-5% 1/1 1 PCS R161 61L0603472 CHIPR 4.7K OHM +-5% 1/1 1 PCS R162 61L0603472 CHIPR 4.7K OHM +-5% 1/1 1 PCS R163 61L0603472 CHIPR 4.7K OHM +-5% 1/1 1 PCS R168 61L0603472 CHIPR 4.7K OHM +-5% 1/1 1 PCS R117 61L0603473 CHIP 47K OHM 1/10W 1 PCS R118 61L0603473 CHIP 47K OHM 1/10W 1 PCS R156 61L0603473 CHIP 47K OHM 1/10W 1 PCS R106 61L0603750 9F 75OHM 1% 1/10W 1 PCS R107 61L0603750 9F 75OHM 1% 1/10W 1 PCS R108 61L0603750 9F 75OHM 1% 1/10W 1 PCS R172 61L1206331 CHIP 330OHM 5% 1/4W 1 PCS C147 65L0603100 31 CHIP 10PF+-0.5PF 50V NP 1 PCS C148 65L0603100 31 CHIP 10PF+-0.5PF 50V NP 1 PCS C152 65L0603102 32 1000PF +-10% 50V X7R 1 PCS C153 65L0603102 32 1000PF +-10% 50V X7R 1 PCS C154 65L0603102 32 1000PF +-10% 50V X7R 1 PCS C155 65L0603102 32 1000PF +-10% 50V X7R 1 PCS C156 65L0603102 32 1000PF +-10% 50V X7R 1 PCS C157 65L0603102 32 1000PF +-10% 50V X7R 1 PCS C119 65L0603104 12 0.1UF +-10% 16V X7R 1 PCS C123 65L0603104 12 0.1UF +-10% 16V X7R 1 PCS C124 65L0603104 12 0.1UF +-10% 16V X7R 1 PCS C125 65L0603104 12 0.1UF +-10% 16V X7R 1 PCS C126 65L0603104 12 0.1UF +-10% 16V X7R 1 PCS C127 65L0603104 12 0.1UF +-10% 16V X7R 1 PCS C128 65L0603104 12 0.1UF +-10% 16V X7R 1 PCS C130 65L0603104 12 0.1UF +-10% 16V X7R 1 PCS C131 65L0603104 12 0.1UF +-10% 16V X7R 1 PCS 46 DELL E173FP Service Manual C132 65L0603104 12 0.1UF +-10% 16V X7R 1 PCS C133 65L0603104 12 0.1UF +-10% 16V X7R 1 PCS C134 65L0603104 12 0.1UF +-10% 16V X7R 1 PCS C135 65L0603104 12 0.1UF +-10% 16V X7R 1 PCS C137 65L0603104 12 0.1UF +-10% 16V X7R 1 PCS C138 65L0603104 12 0.1UF +-10% 16V X7R 1 PCS C139 65L0603104 12 0.1UF +-10% 16V X7R 1 PCS C141 65L0603104 12 0.1UF +-10% 16V X7R 1 PCS C142 65L0603104 12 0.1UF +-10% 16V X7R 1 PCS C144 65L0603104 12 0.1UF +-10% 16V X7R 1 PCS C145 65L0603104 12 0.1UF +-10% 16V X7R 1 PCS C149 65L0603104 12 0.1UF +-10% 16V X7R 1 PCS C150 65L0603104 12 0.1UF +-10% 16V X7R 1 PCS C159 65L0603104 12 0.1UF +-10% 16V X7R 1 PCS C163 65L0603104 12 0.1UF +-10% 16V X7R 1 PCS C164 65L0603104 12 0.1UF +-10% 16V X7R 1 PCS C167 65L0603104 12 0.1UF +-10% 16V X7R 1 PCS C168 65L0603104 12 0.1UF +-10% 16V X7R 1 PCS C173 65L0603104 12 0.1UF +-10% 16V X7R 1 PCS C174 65L0603104 12 0.1UF +-10% 16V X7R 1 PCS C175 65L0603104 12 0.1UF +-10% 16V X7R 1 PCS C104 65L0603473 32 CHIP 0.047UF 50V X7R 1 PCS C106 65L0603473 32 CHIP 0.047UF 50V X7R 1 PCS C108 65L0603473 32 CHIP 0.047UF 50V X7R 1 PCS C112 65L0603473 32 CHIP 0.047UF 50V X7R 1 PCS C113 65L0603473 32 CHIP 0.047UF 50V X7R 1 PCS C114 65L0603473 32 CHIP 0.047UF 50V X7R 1 PCS FB105 71L 56K121 CHIP BEAD 120OHM 6A 1 PCS L101 71L 56K121 CHIP BEAD 120OHM 6A 1 PCS L102 71L 56K121 CHIP BEAD 120OHM 6A 1 PCS L103 71L 56K121 CHIP BEAD 120OHM 6A 1 PCS L104 71L 56K121 CHIP BEAD 120OHM 6A 1 PCS L105 71L 56K121 CHIP BEAD 120OHM 6A 1 PCS L106 71L 56K121 CHIP BEAD 120OHM 6A 1 PCS R101 71L 59Q101 CHIP BEAD 100 OHM 1 PCS R104 71L 59Q101 CHIP BEAD 100 OHM 1 PCS R105 71L 59Q101 CHIP BEAD 100 OHM 1 PCS U101 87L 202 44 PLCC SMT CONN PD41C-441 1 PCS D102 93L 39146 LL5232B SMT 0 PCS D103 93L 39146 LL5232B SMT 0 PCS 47 DELL E173FP Service Manual D104 93L 39146 LL5232B SMT 0 PCS D107 93L 39146 LL5232B SMT 0 PCS D108 93L 39146 LL5232B SMT 0 PCS D109 93L 39146 LL5232B SMT 0 PCS D111 93L 39146 LL5232B SMT 0 PCS D112 93L 39146 LL5232B SMT 0 PCS D102 93L 39149 MLL5232B BY FULL POWER 1 PCS D103 93L 39149 MLL5232B BY FULL POWER 1 PCS D104 93L 39149 MLL5232B BY FULL POWER 1 PCS D107 93L 39149 MLL5232B BY FULL POWER 1 PCS D108 93L 39149 MLL5232B BY FULL POWER 1 PCS D109 93L 39149 MLL5232B BY FULL POWER 1 PCS D111 93L 39149 MLL5232B BY FULL POWER 1 PCS D112 93L 39149 MLL5232B BY FULL POWER 1 PCS D110 93L 60230 BAT54C(L43) 1 PCS D101 93L 64 33 BAV99 0 PCS D105 93L 64 33 BAV99 0 PCS D106 93L 64 33 BAV99 0 PCS D101 93L 6433P BAV99 1 PCS D105 93L 6433P BAV99 1 PCS D106 93L 6433P BAV99 1 PCS DELL MAIN BOARD 1 PCS 715L1280 -------- D ------------------- -------------------------- -------- ----- PARENT NO: KEPC780KED1 KEY BOARD -------- ------------------- -------------------------- -------- ----- R101 61L 60210152T 100OHM +- 5% 1/6W 1 PCS SW101 77L 600 4 HJ TACT SWITCH TSPE-1 1 PCS SW102 77L 600 4 HJ TACT SWITCH TSPE-1 1 PCS SW103 77L 600 4 HJ TACT SWITCH TSPE-1 1 PCS SW104 77L 600 4 HJ TACT SWITCH TSPE-1 1 PCS DP101 81L LED 1 PCS CN101 95L8014 WURE HARNESS 1 PCS PCB 1 PCS 12 1A GP 8 10 715L1153 1A -------PARENT NO: -------- ------------------- -------------------------- -------- ----PWPC1742LGD1 POWER BOARD ------------------- -------------------------- -------- ----PW1742LGD1AI POWER BOARD 1 PCS PW1742LGD1SMT POWER BOARD 1 PCS CON201 33L8021 2D E WAFER 0 PCS CON202 33L8021 2D E WAFER 0 PCS 48 DELL E173FP Service Manual CON203 33L8021 2D E WAFER 0 PCS CON204 33L8021 2D E WAFER 0 PCS CON201 33L8021 2D AC CONN.2P R/A 87210-0236 1 PCS CON202 33L8021 2D AC CONN.2P R/A 87210-0236 1 PCS CON203 33L8021 2D AC CONN.2P R/A 87210-0236 1 PCS CON204 33L8021 2D AC CONN.2P R/A 87210-0236 1 PCS CN901 33L8029 4A PLUG 1 PCS 40L 45762420A ID LABEL 1 PCS IC902 56L 139 3B PC123 Y82 1 PCS IC901 56L 379 32 SG6841D BY SYSTEM 1 PCS Q209 57L 761 6 2SC5706 DIP SANYO 1 PCS Q210 57L 761 6 2SC5706 DIP SANYO 1 PCS Q211 57L 761 6 2SC5706 DIP SANYO 1 PCS Q212 57L 761 6 2SC5706 DIP SANYO 1 PCS NR901 61L NTCR 12OHM 20% 2A SCK-1 1 PCS C903 63L 107474 5S 0.47UF +-10% 250VAC 0 PCS C903 63L 107474 FS 0.47UF +-10% 250VAC 0 PCS C903 63L 107474 HS 0.47UF +-10% 250VAC 0 PCS C903 63L 10747410S 0.47UF +-10% 250VAC 1 PCS C213 63L210J1842A2 PMS 0.18UF 250V 1 PCS C214 63L210J1842A2 PMS 0.18UF 250V 1 PCS C213 64L180J184AAT CAP 0.18UF 160V R79 0 PCS C214 64L180J184AAT CAP 0.18UF 160V R79 0 PCS C226 65L 3J2206EM 22PF 5% 3KV MURATA 0 PCS C227 65L 3J2206EM 22PF 5% 3KV MURATA 0 PCS C228 65L 3J2206EM 22PF 5% 3KV MURATA 0 PCS C229 65L 3J2206EM 22PF 5% 3KV MURATA 0 PCS C226 65L 3J2206ET 22PF 5% 3KV TDK 1 PCS C227 65L 3J2206ET 22PF 5% 3KV TDK 1 PCS C228 65L 3J2206ET 22PF 5% 3KV TDK 1 PCS C229 65L 3J2206ET 22PF 5% 3KV TDK 1 PCS C901 65L305M1022B2 1000PF 400VAC/250VAC 0 PCS C902 65L305M1022B2 1000PF 400VAC/250VAC 0 PCS C901 65L305M1022EM 1000PF +-20% 250VAC/400 1 PCS C902 65L305M1022EM 1000PF +-20% 250VAC/400 1 PCS C913 65L306M3322F2 3300PF +-20% 400VAC Y1 1 PCS C912 65L306M4722B2 4700PF +-20% 400VAC Y1 1 PCS C922 67L215C102 3H EC LESR 1000UF16V HERME 1 PCS C923 67L215C102 3H EC LESR 1000UF16V HERME 1 PCS C922 67L215C102 3K 1000UF/16V 0 PCS 58120 WT 49 DELL E173FP Service Manual C923 67L215C102 3K 1000UF/16V 0 PCS C904 67L215S10115H 100UF 450V 18*36 105 BY 0 PCS C904 67L215S10115K 100UF 450V 0 PCS C904 67L215S10115N 100UF+-20% 450V 1 PCS C922 67L215S102 3N EC 105 16V 1000UF KZE16 0 PCS C923 67L215S102 3N EC 105 16V 1000UF KZE16 0 PCS 71L A 1 PCS 55 2 FERRITE BEAD 6.5*5*1.7 L902 73L 174 26 LS COMMON CHOKE 0 PCS L902 73L 174 26 T1 LINE LILTER 0.45mm 1 PCS L203 73L 174 30 H FILTER 500MH HA 0 PCS L204 73L 174 30 H FILTER 500MH HA 0 PCS L203 73L 174 30 LS FILTER 0 PCS L204 73L 174 30 LS FILTER 0 PCS L203 73L 174 30 YS FILTER 1 PCS L204 73L 174 30 YS FILTER 1 PCS L903 73L 253 91 L CHOKE BY LI TA 0 PCS L904 73L 253 91 L CHOKE BY LI TA 0 PCS L903 73L 253 91 LS CHOKE BY LI SHIN 1 PCS L904 73L 253 91 LS CHOKE BY LI SHIN 1 PCS L201 73L 253139 YL CHOKE 1 PCS L202 73L 253139 YL CHOKE 1 PCS PT201 80LL15T 7 DN X'FMR 0 PCS PT202 80LL15T 7 DN X'FMR 0 PCS PT201 80LL15T 7 YS X'FMR 1 PCS PT202 80LL15T 7 YS X'FMR 1 PCS T901 80LL17T 2 X'FMR 1 PCS T901 80LL17T 2 LS ADAPTOR BY LISHIN 0 PCS BD901 93L BRIDGE 2KBP06M2A600V 1 PCS CON102 95L8014 PIN HEADER 1 PCS 705L 560 57 DL D910/D911 ASS'Y 1 PCS 705L 560 61 05 R917 ASS'Y 1 PCS 705L 560 61 06 R903 ASS'Y 1 PCS 705L 780 57 DL Q903 ASS'Y 1 PCS -------- 50460 T 8 6 19 ------------------- -------------------------- -------- ----- PARENT NO: PW1742LGD1AI POWER BOARD -------- ------------------- -------------------------- -------- ----- CN901 6L 31500 EYELET 2 PCS C213 6L 31502 1.5MM RIVET 2 PCS C214 6L 31502 1.5MM RIVET 2 PCS C904 6L 31502 1.5MM RIVET 2 PCS 50 DELL E173FP Service Manual L902 6L 31502 1.5MM RIVET 4 PCS PT201 6L 31502 1.5MM RIVET 2 PCS PT202 6L 31502 1.5MM RIVET 2 PCS T901 6L 31502 1.5MM RIVET 4 PCS POWER BOARD 1 PCS 715L1283 2 J001 95L 90 23 TIN COATED 0 PCS J002 95L 90 23 TIN COATED 0 PCS J003 95L 90 23 TIN COATED 0 PCS J004 95L 90 23 TIN COATED 0 PCS J005 95L 90 23 TIN COATED 0 PCS J006 95L 90 23 TIN COATED 0 PCS J007 95L 90 23 TIN COATED 0 PCS J008 95L 90 23 TIN COATED 0 PCS J009 95L 90 23 TIN COATED 0 PCS J010 95L 90 23 TIN COATED 0 PCS J011 95L 90 23 TIN COATED 0 PCS J012 95L 90 23 TIN COATED 0 PCS J014 95L 90 23 TIN COATED 0 PCS J015 95L 90 23 TIN COATED 0 PCS J016 95L 90 23 TIN COATED 0 PCS J017 95L 90 23 TIN COATED 0 PCS J018 95L 90 23 TIN COATED 0 PCS J020 95L 90 23 TIN COATED 0 PCS J021 95L 90 23 TIN COATED 0 PCS L205 95L 90 23 TIN COATED 0 PCS L206 95L 90 23 TIN COATED 0 PCS R927 95L 90 23 TIN COATED 1 PCS R915 61L 17210052T 100HM 5% 1/4W 1 PCS R929 61L 17210152T 100 OHM 5% 1/4W 1 PCS R224 61L 17210252T 1K OHM 5% 1/4W 1 PCS R225 61L 17210252T 1K OHM 5% 1/4W 1 PCS R226 61L 17210252T 1K OHM 5% 1/4W 1 PCS R227 61L 17210252T 1K OHM 5% 1/4W 1 PCS R228 61L 17210252T 1K OHM 5% 1/4W 1 PCS R229 61L 17210252T 1K OHM 5% 1/4W 1 PCS R230 61L 17210252T 1K OHM 5% 1/4W 1 PCS R231 61L 17210252T 1K OHM 5% 1/4W 1 PCS R232 61L 17210252T 1K OHM 5% 1/4W 1 PCS R233 61L 17210252T 1K OHM 5% 1/4W 1 PCS R925 61L 17210252T 1K OHM 5% 1/4W 1 PCS 51 DELL E173FP Service Manual R926 61L 17210252T 1K OHM 5% 1/4W 1 PCS R916 61L 17210352T CFR 10KOHM +-5% 1/4W 1 PCS R924 61L 20024252T 2.4KOHM 1% 1/4W 1 PCS R922 61L 20033352T 33KOHM 1% 1/4W 1 PCS R923 61L 20036252T 3.6KOHM 1% 1/4W 1 PCS R201 61L 60224352T 24K OHM 5% 1/6W 1 PCS R920 61L175L47052T 47OHM +-5% 1/2W 1 PCS R921 61L175L47052T 47OHM +-5% 1/2W 1 PCS R904 61L214Y10552T 1M,1/4W 1 PCS R905 61L214Y10552T 1M,1/4W 1 PCS R906 61L214Y10552T 1M,1/4W 1 PCS R907 61L214Y10552T 1M,1/4W 1 PCS FB901 71L 55 29 FERRITE BEAD 1 PCS ZD902 93L 39 5452T ZENER HZ12B2 1 PCS ZD903 93L 39 7752T ZENER HZ5C1 1 PCS D901 93L 6026T52T RECTIFIER DIODE FR107 1 PCS D902 93L 6038P52T PS102R 1 PCS D205 93L 64 1152T 1N4148 1 PCS D206 93L 64 1152T 1N4148 1 PCS D207 93L 64 1152T 1N4148 1 PCS D208 93L 64 1152T 1N4148 1 PCS D209 93L 64 1152T 1N4148 1 PCS D210 93L 64 1152T 1N4148 1 PCS D903 93L 64 1152T 1N4148 1 PCS IC903 56L 158 4 T A 1 PCS Q902 57L 419 PP T 2PC945P 1 PCS Q901 57L 420 PP T 2PA733P 1 PCS C929 64L700J1040AT 0.1UF 50V PEN 1 PCS C905 65L 2K152 1T6052 1.5NF/2KV Y5P +-10% 0 PCS C905 65L 2K152 1T6285 1.5NF/2KV Y5P +-10% 0 PCS C905 65L 2K152 1T6921 1.5NF/2KV Y5P +-10% 1 PCS C920 65L517K102 5T 1000PF 10% Y5P 500V 1 PCS C921 65L517K102 5T 1000PF 10% Y5P 500V 1 PCS C906 67L 305220 7T 22UF +-20% 50V 1 PCS C207 67L 305330 7T 33UF 105 1 PCS C924 67L215B4713HT 470UF 16V LTR471M1CF11V 1 PCS C925 67L215B4713HT 470UF 16V LTR471M1CF11V 1 PCS C924 67L215B4713KT LOW ESR 470UF16V BY HER 0 PCS C925 67L215B4713KT LOW ESR 470UF16V BY HER 0 PCS C201 67L215C1514HT LOW ESR 150UF 25V 8*7MM 1 PCS HTL431 52 DELL E173FP Service Manual C223 67L215C1514HT LOW ESR 150UF 25V 8*7MM 1 PCS C924 67L215N4713NT EC 105 16V 470UF KZE16V 0 PCS C925 67L215N4713NT EC 105 16V 470UF KZE16V 0 PCS F901 84L FUSE 2A 250V WICKMANN 1 PCS -------- ------------------- -------------------------- -------- ----- PARENT NO: 56 1 PW1742LGD1SMT POWER BOARD -------- ------------------- -------------------------- -------- ----- U201 56L 608 1 TL1451ACD 1 PCS U201 56L 622 1 BA9741F-SMT 0 PCS Q205 57L 417 4 PMBS3904/PHILIPS-SMT(04 1 PCS Q206 57L 417 4 PMBS3904/PHILIPS-SMT(04 1 PCS Q207 57L 417 6 PMBS3906/PHILIPS-SMT(06 1 PCS Q208 57L 417 6 PMBS3906/PHILIPS-SMT(06 1 PCS Q203 57L 600 37 STS6PF30L SO-8 0 PCS Q204 57L 600 37 STS6PF30L SO-8 0 PCS Q202 57L 760 4 DTA144WKA BY ROHM SMT(7 1 PCS Q201 57L 760 5 DTC144WKA BY ROHM SMT(8 1 PCS Q203 57L 763 3 AO4411 SO-8 BY AOS SMT 0 PCS Q204 57L 763 3 AO4411 SO-8 BY AOS SMT 0 PCS Q203 57L 763 4 RSS050P03 1 PCS Q204 57L 763 4 RSS050P03 1 PCS R204 61L0603103 CHIPR 10K OHM +-5% 1/10 1 PCS R210 61L0603123 CHIP 12K OHM 1/10W 1 PCS R211 61L0603123 CHIP 12K OHM 1/10W 1 PCS R220 61L0603123 CHIP 12K OHM 1/10W 1 PCS R221 61L0603123 CHIP 12K OHM 1/10W 1 PCS R238 61L0603123 CHIP 12K OHM 1/10W 1 PCS R239 61L0603123 CHIP 12K OHM 1/10W 1 PCS R222 61L0603153 CHIPR 15KOHM+-5% 1/10W 1 PCS R223 61L0603153 CHIPR 15KOHM+-5% 1/10W 1 PCS R216 61L0603221 CHIPR 220 OHM+-5% 1/10W 1 PCS R217 61L0603221 CHIPR 220 OHM+-5% 1/10W 1 PCS R212 61L0603392 CHIP 3.9K OHM 1/10W 1 PCS R213 61L0603392 CHIP 3.9K OHM 1/10W 1 PCS R214 61L0603392 CHIP 3.9K OHM 1/10W 1 PCS R215 61L0603392 CHIP 3.9K OHM 1/10W 1 PCS R218 61L0603471 CHIPR 470 OHM+-5% 1/10W 1 PCS R219 61L0603471 CHIPR 470 OHM+-5% 1/10W 1 PCS R208 61L0603472 CHIPR 4.7K OHM +-5% 1/1 1 PCS R209 61L0603472 CHIPR 4.7K OHM +-5% 1/1 1 PCS 53 DELL E173FP Service Manual R236 61L0603511 CHIPR 510 OHM+-5% 1/10W 1 PCS R237 61L0603511 CHIPR 510 OHM+-5% 1/10W 1 PCS R202 61L0603512 CHIP 5.1K OHM 1/10W 1 PCS R203 61L0603512 CHIP 5.1K OHM 1/10W 1 PCS R240 61L0603513 CHIP 51K OHM 1/10W 1 PCS R241 61L0603513 CHIP 51K OHM 1/10W 1 PCS R234 61L0603621 CHIPR 620 OHM+-5% 1/10W 1 PCS R235 61L0603621 CHIPR 620 OHM+-5% 1/10W 1 PCS R205 61L0603683 CHIP 68K OHM 1/10W 1 PCS R206 61L0603683 CHIP 68K OHM 1/10W 1 PCS F201 61L1206000 CHIPR 0 OHM +-5% 1/4W 1 PCS R912 61L1206101 CHIP 100 OHM 5% 1/4W 1 PCS R928 61L1206102 CHIP 1K OHM 5% 1/4W 1 PCS R913 61L1206103 CHIP 10KOHM 5% 1/4W 1 PCS R901 61L1206105 CHIP 1MOHM 5% 1/4W 1 PCS R902 61L1206105 CHIP 1MOHM 5% 1/4W 1 PCS R914 61L1206243 CHIP 24K OHM 5% 1/4W 1 PCS R909 61L1206472 CHIP 4.7KOHM 5% 1/4W 1 PCS R910 61L1206472 CHIP 4.7KOHM 5% 1/4W 1 PCS R911 61L1206472 CHIP 4.7KOHM 5% 1/4W 1 PCS R908 61L1206519 CHIPR 510OHM +-5% 1/4W 1 PCS C230 65L0805102 32 CHIP 1000P 50VX7R 0805 1 PCS C231 65L0805102 32 CHIP 1000P 50VX7R 0805 1 PCS C910 65L0805102 32 CHIP 1000P 50VX7R 0805 1 PCS C930 65L0805102 32 CHIP 1000P 50VX7R 0805 1 PCS C931 65L0805102 32 CHIP 1000P 50VX7R 0805 1 PCS C202 65L0805104 22 0.1UF +-10% 25V X7R 080 1 PCS C204 65L0805104 22 0.1UF +-10% 25V X7R 080 1 PCS C205 65L0805104 22 0.1UF +-10% 25V X7R 080 1 PCS C206 65L0805104 22 0.1UF +-10% 25V X7R 080 1 PCS C907 65L0805104 32 CHIP 0.1UF 50V X7R 1 PCS C908 65L0805104 32 CHIP 0.1UF 50V X7R 1 PCS C909 65L0805104 32 CHIP 0.1UF 50V X7R 1 PCS C926 65L0805104 32 CHIP 0.1UF 50V X7R 1 PCS C927 65L0805104 32 CHIP 0.1UF 50V X7R 1 PCS C203 65L0805105 22 CHIP 1UF 25V X7R 0805 1 PCS C209 65L0805105 22 CHIP 1UF 25V X7R 0805 1 PCS C210 65L0805105 22 CHIP 1UF 25V X7R 0805 1 PCS C211 65L0805105 22 CHIP 1UF 25V X7R 0805 1 PCS C212 65L0805105 22 CHIP 1UF 25V X7R 0805 1 PCS 54 DELL E173FP Service Manual C219 65L0805105 22 CHIP 1UF 25V X7R 0805 1 PCS C220 65L0805105 22 CHIP 1UF 25V X7R 0805 1 PCS C208 65L0805331 32 CHIP 330PF 50V X7R 0805 1 PCS C221 65L0805474 22 CHIP 0.47UF 25V X7R 080 1 PCS C222 65L0805474 22 CHIP 0.47UF 25V X7R 080 1 PCS D203 93L 39S 3 T BZT52-C11 0 PCS D204 93L 39S 3 T BZT52-C11 0 PCS D203 93L 39S 8 T ZD RLZ11B ROHM 1 PCS D204 93L 39S 8 T ZD RLZ11B ROHM 1 PCS ZD901 93L 39S 12 T RLZ20B BY ROHM 1 PCS ZD904 93L 39S 16 T SML4737A/1 0 PCS ZD904 93L 39S 19 T PTZ7.5B 1 PCS D201 93L2004 2A SM240A 0 PCS D202 93L2004 2A SM240A 0 PCS D201 93L3004 1 SMAL340XXXRO 3A 40V SMA 0 PCS D202 93L3004 1 SMAL340XXXRO 3A 40V SMA 0 PCS D201 93L3004 2 SR34 PAN JIT 1 PCS D202 93L3004 2 SR34 PAN JIT 1 PCS -------- ------------------- -------------------------- -------- ----- PARENT NO: 705L 560 57 DL -------- D910/D911 ASS'Y ------------------- -------------------------- -------- ----90L6064 1 HEAT SINK 1 PCS D911 93L 60235 FCQ10A06(F10P06Q) 1 PCS D911 93L 60236 FMB-26L 0 PCS D910 93L 60238 FCH10A15 T0-220 1 PCS D910 93L 60239 FME-210B 0 PCS M1L1730 -------PARENT NO: 8128 T0-220 SCREW M3x8 2 PCS ------------------- -------------------------- -------- ----705L 560 61 05 R917 ASS'Y -------- ------------------- -------------------------- -------- ----- R917 61L 2J39858H 0.390OHM 5% 2W 1 PCS 96L 29 SHRINK TUBE UL/CSA 1 PCS -------PARENT NO: 6 ------------------- -------------------------- -------- ----705L 560 61 06 R903 ASS'Y -------- ------------------- -------------------------- -------- ----- R903 61L152M10458F 100K OHM 5% 2W 1 PCS 96L SHRINK TUBE UL/CSA 1 PCS -------- 29 6 ------------------- -------------------------- -------- ----- PARENT NO: 705L 780 57 DL -------- Q903 ASS'Y ------------------- -------------------------- -------- ----55 DELL E173FP Service Manual Q903 57L 600 35 STP8NK80ZFP 0 PCS Q903 57L 667 15 FQPF7N80 1 PCS 90L6064 1 HEAT SINK 1 PCS M1L1730 8128 SCREW M3x8 1 PCS -------PARENT NO: -------- -------PARENT NO: -------- TO-220F ------------------- -------------------------- -------- ----705L 780 87 DL CN901 ASS'Y ------------------- -------------------------- -------- ----87L 501 14 RF AC SOCKET 1 PCS 95L 900 42 HARNESS 1 PCS 95L8021 2508 WIRE HARNESS 1 PCS 96L 6 SHRINK TUBE UL/CSA 3 PCS 29 ------------------- -------------------------- -------- ----705L780KB34 79 BACK COVER ASS'Y ------------------- -------------------------- -------- ----12L 394 5 FOOT PORON 0 PCS 15L8053 1 BRACKET BASE 1 PCS 20L 015 1 RISER DIECASTING 1 PCS 34L1369 Y2 T VESA COVER 1 PCS 34L1370 Y2 T STAND FRANT 1 PCS 34L1371 Y2 T STAND BACK 1 PCS 34L1372 Y2 T BASE 1 PCS 37L 483 2 HINGE 1 PCS M1L 130 8225 SCREW 3 PCS M1L 140 8 47 SRCEW 4 PCS Q1L 330 8 47 SCREW 3X8mm 4 PCS Q1L 330 8 47 SCREW 3X8mm 2 PCS 56