Download Crimzon Development Board Accessory Kit User Manual.

ZCRMZN00100KITG
Crimzon® Development
Board Kit
PUG002601-1207
Product User Guide
Introduction
Zilog’s ZCRMZN00100KITG Crimzon® Development Board Kit is designed for use as a
target with the Crimzon In-Circuit Emulator (ZCRMZNICE01ZEMG). The kit is powered
by two 1.5 V AAA batteries (see Figure 1). The development board can also be powered
using an adjustable DC power supply connected to input jack J13. This product user guide
helps you to install the batteries supplied with the accessory kit and tells how to verify
proper development board operation.
Kit Contents
The kit contents are listed below:
• One development board with no silicon installed
• Two 1.5 V AAA batteries
Applying Power to Development Board
Follow the steps below to apply battery power to the development board:
1. Install the two 1.5 V AAA batteries in the battery holder on the bottom of the
development board. When installing the batteries, ensure that the batteries are fully
seated in the battery holder by rotating each battery after snapping it into place.
2. Set switch SW6 (see Figure 1) to the BATTERY position.
Follow the steps below to use an adjustable DC power supply to the development board:
1. Set switch SW6 (see Figure 1) to the EXTERNAL position.
2. Connect the adjustable DC power supply to jack J13 (see Figure 1).
For more information on using the Crimzon development board accessory kit to develop
IR applications, refer to the Crimzon In-Circuit Emulator User Manual (UM0217).
Copyright ©2007 by Zilog®, Inc. All rights reserved.
www.zilog.com
Crimzon® Development Board Kit
Switch
SW6
External
DC Power
Jack J13
Figure 1. Crimzon® Development Board Kit
PUG002601-1207
Page 2 of 8
Crimzon® Development Board Kit
5
4
3
2
1
J2
J1
HDR#
NAME
P00
P01
P02
P03
P04
P05
P06
P07
SHUNT POSITION
INTERNAL IR AMP
2-4 ON
EXTERNAL IR AMP
1-2 ON
3-4 ON
J20
D
Default: On
1
2
3
4
5
6
7
8
U1
1
2
3
4
PORT 0
C1
Vbat
2
1
HDR/PIN 1x2
C2
D
A0
A1
A2
GND
VCC
WP
SCL
SDA
8
7
6
5
GND
SCL
SDA
AT24C256
8-pin PDIP socket
R1
R2
10K
10K
J3
3300PF
Vbat
2
1
2.2M ohm
C3
2
R6
1
10K
2
J20
1
10K
2
1
3
6.8K ohm
2
4
Vbat
0.047uF
C4
14
1
7
U2A
2
U2B
4
3
74HCU04
74HCU04
Vbat
7
U2E
12
13
14
11
14
14
74HCU04
Vbat
74HCU04
J5
HDR/PIN 1x1
R10
330 ohm
0.1uF
Vbat
R11
10 ohm
D2
RED
C5
74HCU04
C
Vbat
1
2
3
4
5
6
7
8
PORT 3
9
1
10
8
U2F
Vbat
TEST POINTS
1
7
7
R13
110K
J4
P30
P31
P32
P33
P34
P35
P36
P37
P31
Vbat
R12
10K
U2D
Vbat
LTR-516AD
5
Vbat
Vbat
Vbat
PORT 2
U2C
6
74HCU04
14
R8
560 ohm
R9
47K
14
7
0.047uF
C
7
D1
Vbat
P35_OUT
P35_OUT
J6
D3
LTE-5208A
3
1
R7
10K
R5
1
2
3
4
5
6
7
8
1
R4
R3
DEFAULT: 2-4 ON
P20
P21
P22
P23
P24
P25
P26
P27
2
3300PF
R14
HDR/PIN 1x1
Q1
2N3904
2
P36_OUT
Vbat
1
330 ohm
B
B
U3
3
V+
0.1uF
C8
7
P1
V-
0.1uF
5
9
4
8
3
7
2
6
1
TxD
13
T1OUT
C1+
2
C7
C1-
4
0.1uF
C2+
5
C9
C2-
6
0.1uF
T1IN
11
J7
GND
GND
Vbat
Vbat
TX
Default: OFF
1
2
C6
P07
RX
8
R1IN
R1OUT
9
15
VDD
EN
1
J8
1
2
RxD
P32
Vbat
Vbat
C10
0.1uF
DB9 FEM/RT
14
A
Default: OFF
SHDN
HDR#
GND
SP3220EBCA
NAME
DEFAULT SHUNT POSITION
J7
Tx Enable
1-2 OFF
J8
Rx Enable
1-2 OFF
16
ZiLOG Inc.
A
6800 Santa Teresa Blvd
San Jose, CA 95119
408-513-1500
Website: www.zilog.com
Title
Vbat
ZLF645 DEVELOPMENT BOARD
Size
B
Date:
5
4
3
2
Document Number
96C1031-001G
Monday, August 27, 2007
Rev
B
Sheet
1
of
5
1
Figure 2. Schematics (1 of 5)
PUG002601-1207
Page 3 of 8
Crimzon® Development Board Kit
5
4
3
P25
P26
P27
P04
P05
P06
P07
VBAT
XOUT
XIN
P31
P32
P33
P34
D
Y1
P31
P32
P33
P34
8MHZ
C12
C11
22pF
1
2
3
4
5
6
7
8
9
10
11
12
13
14
2
1
U5
U4
P25
P26
P27
P04
P05
P06
P07
VDD
XTAL2
XTAL1
P31
P32
P33
P34
P24
P23
P22
P21
P20
P03
GND
P02
P01
P00
P30
P36
P37
P35
28
27
26
25
24
23
22
21
20
19
18
17
16
15
P24
P23
P22
P21
P20
P03
VSS
P02
P01
P00
P30
P36
P37
P35
P25
P26
P27
P07
VBAT
XOUT
XIN
P31
P32
P33
P36
P37
P35
1
2
3
4
5
6
7
8
9
10
R15 330 ohm
1
LED1
P24
P23
P22
P21
P20
GND
P01
P00
P36
P34
20
19
18
17
16
15
14
13
12
11
P25
P24
P26
P23
P27
P22
P07
P21
VDD
P20
XTAL2
VSS
XTAL1
P01
P31
P00/P30
P32
P36
P33
P34
J9
R16 330 ohm
1
LED2
LED3
R17 330 ohm
1
LED4
R18 330 ohm
1
P00
P01
P02
P03
P04
P05
P06
P07
LED5
SCL
SDA
1
3
DIP/8POS
P37
P27
2
4
D7
2
330 ohm
1
D8
2
RED
R20 330 ohm
1
LED6
DEFAULT OFF
D9
2
RED
HDR/PIN 2x2
Vbat
C
J11
GND
2
RED
R19
J10
Vbat
D6
RED
SW2
28pin socket
SCL
SDA
2
D
LED
DEFAULT
1-2 ON
3-4 ON
C
D5
RED
22pF
GND
2
RED
LED1
LED2
LED3
LED4
LED5
LED6
LED7
LED8
1
2
3
4
5
6
7
8
20pin socket
D4
GND
SDA
SCL
Vbat
GND
LED7
R21 330 ohm
1
LED8
R22 330 ohm
1
1
2
3
4
D10
2
RED
I2C
D11
2
RED
R24
Vbat
B
R25
2
3
4
5
6
7
8
9
10
1
P20
P21
P22
P23
P24
P25
P26
P27
2
3
4
5
6
7
8
9
10
DIP/8POS
DEFAULT ALL OFF
SW5
P20
P21
P22
P23
P24
P25
P26
P27
1
P30
P31
P32
P33
P34
P35
P36
P37
P30
P31
P32
P33
P34
P35
P36
P37
Vbat
P34_OUT
P35_OUT
P36_OUT
P37_OUT
DIP/8POS
P34_OUT
P35_OUT
P36_OUT
P37_OUT
2
3
4
5
6
7
8
9
10
1
R26
P34_OUT
680K ohm
B
J12
1
2
3
680K ohm
DEFAULT ALL OFF
Q2
2N3906
2
1K
DIP/8POS
680K ohm
1
SW4
P00
P01
P02
P03
P04
P05
P06
P07
3
R23
SW3
P00
P01
P02
P03
P04
P05
P06
P07
DEFAULT ALL ON
HDR/PIN 1x3
Vbat
DEFAULT
1-2 ON
2
P34
2 4 6
1 3 5
JP1
HDR/PIN 2x3
1
R27
10K
P34
=
DEBUG
ZiLOG Inc.
A
A
6800 Santa Teresa Blvd
San Jose, CA 95119
408-513-1500
Website: www.zilog.com
Title
Vbat
ZLF645 DEVELOPMENT BOARD
Size
B
Date:
5
4
3
2
Document Number
96C1031-001G
Monday, September 10, 2007
Rev
B
Sheet
2
of
5
1
Figure 3. Schematics (2 of 5)
PUG002601-1207
Page 4 of 8
Crimzon® Development Board Kit
5
4
3
2
1
D
D
LABEL: EXTERNAL
SW6
U6
1
1
2
Vbat
3
+ C16
10uF
1
Vin
+ C14
10uF
TAB
Vout
LT1086CM
R28
121 ohm
C15
0.01uF
EG1218
LABEL: BATTERY
J21
2
2
C13
0.1uF
ADJ
1
3
4
2
1
2
R33
DEFAULT: ON
HDR/PIN 1x2
200 ohm
C
C
R30
3
1
1
R31
332 ohm
2
121 ohm
2
R29
200 OHM
2
POWER SUPPLY
D12
GREEN
J13
1
2
1
BT1
3
2
PJ-007
1
BATTERY
NOTE: BT1 use battery holder
B
B
J14
A
Vbat
1
2
3
J15
1
2
3
Vbat
Vbat
Vbat
J16
GND
1
2
3
ZiLOG Inc.
J17
A
1
2
3
GND
GND
6800 Santa Teresa Blvd
San Jose, CA 95119
408-513-1500
Website: www.zilog.com
Title
ZLF645 DEVELOPMENT BOARD
GND
Size
B
Date:
5
4
3
2
Document Number
96C1031-001G
Wednesday, September 12, 2007
Rev
B
Sheet
3
of
5
1
Figure 4. Schematics (3 of 5)
PUG002601-1207
Page 5 of 8
Crimzon® Development Board Kit
5
4
3
2
1
D
D
COL7
COL7
COL6
COL6
K1
COL5
COL5
K2
SUR MODE
SUR ON / TT HOLD
K9
K10
DISC
K17
TAPE
K18
COL4
COL4
K3
FRONT / YELLOW
K11
TUNNER
K19
COL3
COL3
K4
COL2
COL2
K5
CENTER / RED
K12
TELEVISION
K20
COL1
COL1
K6
REAR / GREEN
DELAY / BLUE
K13
K14
VIDEO 1
K21
VIDEO 2
K22
DSP MODE
DSP ON
COL0
COL0
K7
J18
K8
DELAY UP / TT OFF
K15
DELAY DN / TT ON
ROW0
ROW0
K16
AUDIO
K23
TEST
K24
ROW1
PIP
SWAP
ROW2
P20
P21
P22
P23
P24
P25
P26
P27
P20
P21
P22
P23
P24
P25
P26
P27
2
4
6
8
10
12
14
16
COL0
COL1
COL2
COL3
COL4
COL5
COL6
COL7
1
3
5
7
9
11
13
15
HDR/PIN 2x8
ROW1
DEFAULT ALL ON
C
C
J19
K25
K26
K27
K28
K29
K30
K31
K32
REC
K34
STOP
K35
PLAY
K36
PAUSE
K37
REW
K38
FF
K39
AV
K40
ROW3
K33
TV
SAT
DVD
CH+
ROW4
1
2
3
K41
K42
K43
K44
K45
K46
K47
K48
VCR
K49
AMP
K50
AUX
K51
4
K52
5
K53
6
K54
GUIDE
K55
CHK56
INFO
7
8
9
RECALL
VOL+
K60
K61
K62
ROW5
ROW2
ROW3
P00
P01
P02
P03
P04
P05
P06
P07
P00
P01
P02
P03
P04
P05
P06
P07
2
4
6
8
10
12
14
16
1
3
5
7
9
11
13
15
ROW0
ROW1
ROW2
ROW3
ROW4
ROW5
ROW6
ROW7
HDR/PIN 2x8
ROW4
DEFAULT ALL ON
ROW5
B
B
CABLE
K57
K58
POWER
MUTE
K59
MENU
EXIT
0
ENTER
K63
ROW6
ROW6
K64
SELECT
VOL-
ROW7
ROW7
KEYPAD
ZiLOG Inc.
A
A
6800 Santa Teresa Blvd
San Jose, CA 95119
408-513-1500
Website: www.zilog.com
Title
ZLF645 DEVELOPMENT BOARD
Size
B
Date:
5
4
3
2
Document Number
96C1031-001G
Monday, August 27, 2007
Rev
B
Sheet
4
of
5
1
Figure 5. Schematics (4 of 5)
PUG002601-1207
Page 6 of 8
Crimzon® Development Board Kit
5
4
3
2
1
S1
PRO1
G1
PRO10
V1
G6
S5
PROTO-TYPE1
S6
S7
S8
SCREW
SCREW
SCREW
S2
S3
S4
V6
cap_0603
SCREW
cap_0603
BH1
STANDOFF
D
STANDOFF
STANDOFF
STANDOFF
D
PRO2
G2
PRO9
V2
G7
Holder 2xAAA
V7
cap_0603
SOC_U1
cap_0603
MH1
MH2
MH3
MH4
M HOLE1
M HOLE1
M HOLE1
M HOLE1
PRO3
G3
PRO8
V3
G8
proU9
V8
cap_0603
cap_0603
PRO4
G4
PRO7
V4
G9
V9
2
7
1A
2A
5
1
CLMP
S
1Y
2Y
DIPSOC-4x2
3
6
for U1 8PDIP
SHUNT1
SHUNT2
SHUNT3
J2/1-2
J7/1-2
J8/1-2
SHUNT6
SHUNT7
SHUNT5
J10/1-2
J10/3-4
J12/1-2
U4_CONN1
C
cap_0603
PRO5
PRO6
G5
V5
G10
75446
SHUNT8 SHUNT9 SHUNT10SHUNT11SHUNT12SHUNT13
proU8A
V10
1
SHUNT14
U5_CONN2
SHUNT15
C
2
cap_0603
SN74LV05A
J18/1-2
J18/3-4
J18/5-6
J18/7-8
J18/9-10 J18/11-12
J18/13-14
J18/15-16
7
cap_0603
U4_CONN2
U5_CONN1
14
cap_0603
N_VIA1
N_VIA6
VIA_NON CONNECT
N_VIA2
VIA_NON CONNECT
N_VIA7
SHUNT17
SHUNT18
SHUNT19
J19/1-2
J19/3-4
J19/5-6
J19/7-8
SHUNT20
SHUNT21
SHUNT22
SHUNT4
VIA_NON CONNECT
N_VIA3
U5
J19/9-10
V4
VIA_NON CONNECT
N_VIA8
VIA_NON CONNECT
N_VIA9
V5
U4
J19/15-16
U4
U5
for U5 20PDIP
for U4 28PDIP
SHUNT23
SHUNT24
SHUNT25
SN74LVC00
J20/2-4
N_VIA13
VIA_NON CONNECT
VIA_NON CONNECT
N_VIA10
J20/1
J20/3
HARDWARE
G5
V9
VIA_NON CONNECT
N_VIA5
J19/13-14
2
V8
VIA_NON CONNECT
N_VIA4
J19/11-12
3
V7
V3
proU7A
1
7
V2
B
SHUNT16
V6
14
V1
N_VIA14
N_VIA19
G9
G6
B
VIA_NON CONNECT
V10
VIA_NON CONNECT
VIA_NON CONNECT
VIA_NON CONNECT
N_VIA11
N_VIA12
N_VIA20
N_VIA15
G1
G10
G7
G3
VIA_NON CONNECT
VIA_NON CONNECT
VIA_NON CONNECT
VIA_NON CONNECT
N_VIA16
G2
N_VIA17
G4
VIA_NON CONNECT
N_VIA18
G8
VIA_NON CONNECT
VIA_NON CONNECT
ZiLOG Inc.
A
A
6800 Santa Teresa Blvd
San Jose, CA 95119
408-513-1500
Website: www.zilog.com
Title
PROTO-TYPE AREA FOOTPRINT
ZLF645 DEVELOPMENT BOARD
Size
B
Date:
5
4
3
2
Document Number
96C1031-001G
Monday, August 27, 2007
Rev
B
Sheet
5
of
5
1
Figure 6. Schematics (5 of 5)
PUG002601-1207
Page 7 of 8
Crimzon® Development Board Kit
Warning: DO NOT USE IN LIFE SUPPORT
LIFE SUPPORT POLICY
ZILOG'S PRODUCTS ARE NOT AUTHORIZED FOR USE AS CRITICAL
COMPONENTS IN LIFE SUPPORT DEVICES OR SYSTEMS WITHOUT THE
EXPRESS PRIOR WRITTEN APPROVAL OF THE PRESIDENT AND GENERAL
COUNSEL OF ZILOG CORPORATION.
As used herein
Life support devices or systems are devices which (a) are intended for surgical implant
into the body, or (b) support or sustain life and whose failure to perform when properly
used in accordance with instructions for use provided in the labeling can be reasonably
expected to result in a significant injury to the user. A critical component is any
component in a life support device or system whose failure to perform can be reasonably
expected to cause the failure of the life support device or system or to affect its safety or
effectiveness.
Document Disclaimer
©2007 by Zilog, Inc. All rights reserved. Information in this publication concerning the
devices, applications, or technology described is intended to suggest possible uses and
may be superseded. ZILOG, INC. DOES NOT ASSUME LIABILITY FOR OR
PROVIDE A REPRESENTATION OF ACCURACY OF THE INFORMATION,
DEVICES, OR TECHNOLOGY DESCRIBED IN THIS DOCUMENT. ZILOG ALSO
D O E S N O T A S S U M E L I A B I L I T Y F O R I N T E L L E C T U A L P R O P E RT Y
INFRINGEMENT RELATED IN ANY MANNER TO USE OF INFORMATION,
DEVICES, OR TECHNOLOGY DESCRIBED HEREIN OR OTHERWISE. The
information contained within this document has been verified according to the general
principles of electrical and mechanical engineering.
Crimzon is a registered trademark of Zilog, Inc. All other product or service names are the
property of their respective owners.
PUG002601-1207
Page 8 of 8