Download PD-D6-J - Audio Design Guide

ORDER NO.
RRV3531
PD-D6-J
Super Audio CD Player
PD-D6-J
PD-D6-S
THIS MANUAL IS APPLICABLE TO THE FOLLOWING MODEL(S) AND TYPE(S).
Model
Type
Power Requirement
PD-D6-J
KUXJ/CA
AC 120V
PD-D6-J
MYXJ5
AC 220 V to 230 V
PD-D6-S
RLFPWXJ
AC 110 V / 220 V to 240 V
The voltage can be converted by
the following method
with the voltage selector
For details, refer to "Important Check Points for Good Servicing".
PIONEER CORPORATION
4-1, Meguro 1-chome, Meguro-ku, Tokyo 153-8654, Japan
PIONEER ELECTRONICS (USA) INC. P.O. Box 1760, Long Beach, CA 90801-1760, U.S.A.
PIONEER EUROPE NV Haven 1087, Keetberglaan 1, 9120 Melsele, Belgium
PIONEER ELECTRONICS ASIACENTRE PTE. LTD. 253 Alexandra Road, #04-01, Singapore 159936
PIONEER CORPORATION 2006
T-ZZV NOV. 2006 printed in Japan
1
2
3
4
SAFETY INFORMATION
A
This service manual is intended for qualified service technicians; it is not meant for the casual
do-it-yourselfer. Qualified technicians have the necessary test equipment and tools, and have been
trained to properly and safely repair complex products such as those covered by this manual.
Improperly performed repairs can adversely affect the safety and reliability of the product and may
void the warranty. If you are not qualified to perform the repair of this product properly and safely, you
should not risk trying to do so and refer the repair to a qualified service technician.
B
WARNING
This product contains lead in solder and certain electrical parts contain chemicals which are known to the state of California to
cause cancer, birth defects or other reproductive harm.
Health & Safety Code Section 25249.6 – Proposition 65
NOTICE
(FOR CANADIAN MODEL ONLY)
Fuse symbols
(fast operating fuse) and/or
(slow operating fuse) on PCB indicate that replacement
parts must be of identical designation.
REMARQUE
(POUR MODÈLE CANADIEN SEULEMENT)
C
Les symboles de fusible
(fusible de type rapide) et/ou
(fusible de type lent) sur CCI indiquent que
les pièces de remplacement doivent avoir la même désignation.
(FOR USA MODEL ONLY)
1. SAFETY PRECAUTIONS
The following check should be perfor med for the
continued protection of the customer and ser vice
technician.
LEAKAGE CURRENT CHECK
Measure leakage current to a known ear th ground
(water pipe, conduit, etc.) by connecting a leakage
current tester such as Simpson Model 229-2 or
equivalent between the ear th ground and all exposed
metal par ts of the appliance (input/output terminals,
screwheads, metal overlays, control shaft, etc.). Plug
the AC line cord of the appliance directly into a 120V
AC 60 Hz outlet and turn the AC power switch on. Any
current measured must not exceed 0.5 mA.
D
Leakage
current
tester
Device
under
test
E
Reading should
not be above
0.5 mA
Test all
exposed metal
surfaces
Also test with
plug reversed
(Using AC adapter
plug as required)
Earth
ground
ANY MEASUREMENTS NOT WITHIN THE
LIMITS OUTLINED ABOVE ARE INDICATIVE
OF A POTENTIAL SHOCK HAZARD AND
MUST BE CORRECTED BEFORE RETURNING THE APPLIANCE TO THE CUSTOMER.
2. PRODUCT SAFETY NOTICE
Many electrical and mechanical parts in the appliance
have special safety related character istics. These are
often not evident from visual inspection nor the
protection afforded by them necessarily can be obtained
by using replacement components rated for voltage,
wattage, etc. Replacement par ts which have these
special safety character istics are identified in this
Service Manual.
Electr ical components having such features are
identified by marking with a
on the schematics and
on the parts list in this Service Manual.
The use of a substitute replacement component which
does not have the same safety characteristics as the
PIONEER recommended replacement one, shown in the
parts list in this Service Manual, may create shock, fire,
or other hazards.
Product Safety is continuously under review and new
instructions are issued from time to time. For the latest
infor mation, always consult the current PIONEER
Service Manual. A subscription to, or additional copies
of, PIONEER Ser vice Manual may be obtained at a
nominal charge from PIONEER.
AC Leakage Test
F
2
PD-D6-J
1
2
3
4
5
6
7
8
A
WARNING !
THE AEL (ACCESSIBLE EMISSION LEVEL) OF THE LASER POWER OUTPUT IS LESS THAN CLASS 1
BUT THE LASER COMPONENT IS CAPABLE OF EMITTING RADIATION EXCEEDING THE LIMIT FOR
CLASS 1.
A SPECIALLY INSTRUCTED PERSON SHOULD DO SERVICING OPERATION OF THE APPARATUS.
B
LASER DIODE CHARACTERISTICS
FOR CD :
LABEL CHECK
MAXIMUM OUTPUT POWER : 7 mW
WAVELENGTH : 780 nm
(FOR DVD : MAXIMUM OUTPUT POWER : 5 mW
WAVELENGTH : 650 nm)
KUXJ/CA, MYXJ5 types : VRW2257
RLFPWXJ type : VRW2159
C
D
(Printed on the Rear Panel )
Additional Laser Caution
1. Laser Interlock Mechanism
• Loading switch (S101 on the LOAB Assy) is used for interlock
mechanism of the laser.
When this switch turned ON in SW2 (CLOSE) side (OPEN signal is
0V and CLOSE signal is 3.5V), a laser becomes the status which can
completely oscillation.
Furthermore, the laser completely oscillates in the disc judgment and
disc playback.
When player is power ON state and laser diode is not completely
oscillating, 780nm laser diode is always oscillating by half power.
• Laser diode is driving with Q307 (650nm LD) and Q308 (780nm LD)
on the DVDM Assy.
Therefore, when short-circuit between the emitter and collector of these
transistors or the base voltage is supplied for transistors turn on, the
laser oscillates. (failure mode)
• In the test mode ∗ , there is the mode that the laser oscillates except
for the disc judgment and playback. LD ON mode in the test mode
oscillates with the laser forcibly.
The interlock mechanism mentioned above becomes invalid in this
mode.
E
2. When the cover is open, close viewing through the objective lens with
the naked eye will cause exposure to the laser beam.
∗ : Refer to page 58.
F
3
PD-D6-J
5
6
7
8
1
2
3
4
[Important Check Points for Good Servicing]
In this manual, procedures that must be performed during repairs are marked with the below symbol.
Please be sure to confirm and follow these procedures.
A
1. Product safety
Please conform to product regulations (such as safety and radiation regulations), and maintain a safe servicing environment by
following the safety instructions described in this manual.
1 Use specified parts for repair.
Use genuine parts. Be sure to use important parts for safety.
2 Do not perform modifications without proper instructions.
Please follow the specified safety methods when modification(addition/change of parts) is required due to interferences such as
radio/TV interference and foreign noise.
3 Make sure the soldering of repaired locations is properly performed.
B
When you solder while repairing, please be sure that there are no cold solder and other debris.
Soldering should be finished with the proper quantity. (Refer to the example)
4 Make sure the screws are tightly fastened.
Please be sure that all screws are fastened, and that there are no loose screws.
5 Make sure each connectors are correctly inserted.
Please be sure that all connectors are inserted, and that there are no imperfect insertion.
6 Make sure the wiring cables are set to their original state.
Please replace the wiring and cables to the original state after repairs.
In addition, be sure that there are no pinched wires, etc.
C
7 Make sure screws and soldering scraps do not remain inside the product.
Please check that neither solder debris nor screws remain inside the product.
8 There should be no semi-broken wires, scratches, melting, etc. on the coating of the power cord.
Damaged power cords may lead to fire accidents, so please be sure that there are no damages.
If you find a damaged power cord, please exchange it with a suitable one.
9 There should be no spark traces or similar marks on the power plug.
When spark traces or similar marks are found on the power supply plug, please check the connection and advise on secure
connections and suitable usage. Please exchange the power cord if necessary.
0 Safe environment should be secured during servicing.
D
When you perform repairs, please pay attention to static electricity, furniture, household articles, etc. in order to prevent injuries.
Please pay attention to your surroundings and repair safely.
2. Adjustments
To keep the original performance of the products, optimum adjustments and confirmation of characteristics within specification.
Adjustments should be performed in accordance with the procedures/instructions described in this manual.
3. Lubricants, Glues, and Replacement parts
Use grease and adhesives that are equal to the specified substance.
Make sure the proper amount is applied.
E
4. Cleaning
For parts that require cleaning, such as optical pickups, tape deck heads, lenses and mirrors used in projection monitors, proper
cleaning should be performed to restore their performances.
5. Shipping mode and Shipping screws
To protect products from damages or failures during transit, the shipping mode should be set or the shipping screws should be
installed before shipment. Please be sure to follow this method especially if it is specified in this manual.
F
4
PD-D6-J
1
2
3
4
5
6
7
8
CONTENTS
SAFETY INFORMATION......................................................................................................................................2
1. SPECIFICATIONS .............................................................................................................................................6
2. EXPLODED VIEWS AND PARTS LIST.............................................................................................................8
2.1 PACKING ....................................................................................................................................................8
2.2 EXTERIOR SECTION ..............................................................................................................................10
2.3 FRONT PANEL SECTION ........................................................................................................................12
2.4 05 LOADER ASSY ...................................................................................................................................14
2.5 TRAVERSE MECHANISM ASSY-S ..........................................................................................................16
3. BLOCK DIAGRAM AND SCHEMATIC DIAGRAM ..........................................................................................18
3.1 BLOCK DIAGRAM....................................................................................................................................18
3.2 LOAB ASSY and OVERALL WIRING CONNECTION DIAGRAM ............................................................20
3.3 DVDM ASSY (1/2) ....................................................................................................................................22
3.4 DVDM ASSY (2/2) ....................................................................................................................................24
3.5 AJKB ASSY (1/2)......................................................................................................................................26
3.6 AJKB ASSY (2/2)......................................................................................................................................28
3.7 LCD, PLED, MNSW, KEY, CONNECTOR, PRIMARY and TRANS ASSYS..............................................30
3.8 WAVEFORMS...........................................................................................................................................32
4. PCB CONNECTION DIAGRAM ......................................................................................................................35
4.1 LOAB ASSY..............................................................................................................................................35
4.2 DVDM ASSY.............................................................................................................................................36
4.3 AJKB ASSY ..............................................................................................................................................38
4.4 LCD ASSY ................................................................................................................................................40
4.5 PLED, KEY and PRIMARY ASSYS ..........................................................................................................42
4.6 CONNECTOR and MNSW ASSYS ..........................................................................................................44
4.7 PRIMARY ASSY .......................................................................................................................................46
5. PCB PARTS LIST ............................................................................................................................................48
6. ADJUSTMENT ................................................................................................................................................56
6.1 ADJUSTMENT ITEMS AND LOCATION ..................................................................................................56
6.2 JIGS AND MEASURING INSTRUMENTS ...............................................................................................56
6.3 NECESSARY ADJUSTMENT POINTS ....................................................................................................57
6.4 TEST MODE .............................................................................................................................................58
6.5 MECHANISM ADJUSTMENT...................................................................................................................60
7. GENERAL INFORMATION .............................................................................................................................62
7.1 DIAGNOSIS..............................................................................................................................................62
7.1.1 TEST MODE.......................................................................................................................................62
7.1.2 METHOD FOR DIAGNOSING DEGRADATION OF THE LDS ON THE PICKUP ASSY ...................63
7.1.3 TROUBLE SHOOTING.......................................................................................................................64
7.1.4 SEQUENCE AFTER POWER ON/OFF .............................................................................................68
7.1.5 DISASSEMBLY ..................................................................................................................................72
7.1.6 PANEL ADJUSTING...........................................................................................................................80
7.2 PARTS ......................................................................................................................................................81
7.2.1 IC........................................................................................................................................................81
8. PANEL FACILITIES .........................................................................................................................................94
A
B
C
D
E
F
5
PD-D6-J
5
6
7
8
1
2
3
4
1. SPECIFICATIONS
•
General
Disc / content format playback
compatibility
System. . . . . . . . . . . . . . Super Audio CD player
Power requirements(KUXJ/CA) . .AC 120 V, 60 Hz
Power requirements(MYXJ5)
. . . . . . . . . . . . . . .AC 220 V to 230V, 50 / 60 Hz
Power requirements(RLFPWXJ)
. . . AC 110 V, 60 Hz, 220 V to 240V, 50 / 60 Hz
Power consumption. . . . . . . . . . . . . . . . . . .22 W
Power consumption (standby) . . . . . . . . . 0.4 W
Weight . . . . . . . . . . . . . . . . . 4.5 kg (9 lb. 15 oz.)
Dimensions
. . . . . . 420 mm (W) x 100 mm (H) x 340 mm (D)
(16 9/16 in. (W) x 3 15/16 in. (H) x 13 3/8 in. (D)
Operating temperature . . . . . . . . +5
to +35
Operating humidity . . . . . . . . . . . . . .5 % to 85 %
(no condensation)
A
B
•
This player is compatible with a wide range of
audio disc types and media formats. Playable
discs will generally feature one of the following
logos on the disc and/or disc packaging. Note
however that some disc types, such as
recordable CDs, may be in an unplayable
formatósee the Disc compatibility table below
for further compatibility information.
Please also note that recordable discs cannot be
recorded using this player.
Audio output (1 stereo pair)
Output level. . . . . . . . . . . . . During audio output
200 mVrms (1 kHz, -20 dB)
Number of channels . . . . . . . . . . . . . . . . . . . . . 2
Jacks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . RCA
•
•
CD-R
CD-RW
Super Audio CD
Digital audio characteristics
Frequency response . . . 4 Hz to 50 kHz (SACD)
4 Hz to 20 kHz (CD)
S/N ratio:
CD . . . . . . . . . . . . . . . . . . . . . . . . . . . . 118 dB
SACD. . . . . . . . . . . . . . . . . . . . . . . . . . 110 dB
Dynamic range:
CD . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 99 dB
SACD. . . . . . . . . . . . . . . . . . . . . . . . . . 108 dB
Total harmonic distortion:
CD . . . . . . . . . . . . . . . . . . . . . . . . . . . 0.002 %
SACD. . . . . . . . . . . . . . . . . . . . . . . . . 0.003 %
Wow and flutter . . . . . . . . Limit of measurement
(±0.001 % W. PEAK) or lower
C
Audio CD
Digital output
Accessories
• Power cable
(ADG7062 : MYXJ5)
(ADG7061 : KUXJ/CA)
Coaxial digital output. . . . . . . . . . . . . . .RCA jack
Optical digital output. . . . . . . . Optical digital jack
•
Accessories
Remote control . . . . . . . . . . . . . . . . . . . . . . . . . 1
Lithium battery (CR2025) . . . . . . . . . . . . . . . . . 1
RCA/phono stereo audio cable . . . . . . . . . . . . . 1
SR control cable . . . . . . . . . . . . . . . . . . . . . . . . 1
Power cable . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
Operating Instructions
Warranty card
D
The specifications and design of this product are subject
to change without notice, due to improvement.
(ADG7104 : RLFPWXJ)
(ADG7076 : RLFPWXJ)
• RCA/phono stereo audio cable
(XDE3047)
• Remote Control
(PWW1175 : Except RLFPWXJ)
(PWW1176 : RLFPWXJ type)
• SR control cable
(XDE3063)
E
• Lithium Battery (CR2025)
>
(Attached inside the remote control)
F
6
PD-D6-J
1
2
3
4
5
6
7
8
A
B
C
D
E
F
7
PD-D6-J
5
6
7
8
1
2
3
4
2. EXPLODED VIEWS AND PARTS LIST
NOTES:
A
Parts marked by "NSP" are generally unavailable because they are not in our Master Spare Parts List.
The
mark found on some component parts indicates the importance of the safety factor of the part.
Therefore, when replacing, be sure to use parts of identical designation.
Screws adjacent to mark on product are used for disassembly.
For the applying amount of lubricants or glue, follow the instructions in this manual.
(In the case of no amount instructions, apply as you think it appropriate.)
2.1 PACKING
20
21
2
B
23
PD-D6-J/MYXJ5
Only
6
22
PD-D6-S/RLFPWXJ
Only
PD-D6-J/KUXJ/CA
Only
PD-D6-J/KUXJ/CA
PD-D6-J/MYXJ5
Only
11
C
13
4
PD-D6-S/RLFPWXJ
Only
3
9
10
PD-D6-J/MYXJ5
Only
7
16
12
5
14
D
PD-D6-S/RLFPWXJ
Only
PD-D6-J/KUXJ/CA 1
Only
15
17
18
E
19
3
8
PD-D6-S/RLFPWXJ
Only
F
7
8
PD-D6-J
1
2
3
4
5
6
7
8
(1) PACKING SECTION PARTS LIST
Mark No.
Description
Mark No.
Part No.
NSP 1
2
>
3
>
4
5
Energy Star Label
Label (WEEE)
AC Power Cord
AC Power Cord
Packing Sheet
See Contrast table (2)
See Contrast table (2)
See Contrast table (2)
See Contrast table (2)
AHG7010
NSP 6
NSP 7
8
Polyethylene Bag
Literature Bag
Caution Card
(SD SB)
Caution Card
(SB)
Caution Card 220-240
AHG7117
See Contrast table (2)
See Contrast table (2)
9
10
NSP 11
Warranty Card
(EL)
Warranty Card
Operating Instructions
NSP 12
13
14
15
16
17
NSP 18
19
20
See Contrast table (2)
21
22
23
See Contrast table (2)
See Contrast table (2)
Description
Part No.
(English)
Operating Instructions
See Contrast table (2)
(English, French, German, Italian, Dutch, Spanish)
Operating Instructions
See Contrast table (2)
(English, Chinese)
PAD L
PAD R
Spacer
Packing Case
Remote Control Unit
A
PHA1353
PHA1354
PHC1097
See Contrast table (2)
See Contrast table (2)
Battery Cover
See Contrast table (2)
RCA/phono stereo audio cable XDE3047
SR control cable
XDE3063
B
See Contrast table (2)
See Contrast table (2)
(2) CONTRAST TABLE
PD-D6-J/KUXJ/CA, PD-D6-J/MYXJ5 and PD-D6-S/RLFPWXJ are constructed the same except for the following :
PD-D6-J/
KUXJ/CA
PD-D6-J/
MYXJ5
PD-D6-S/
RLFPWXJ
Energy Star Label
Label (WEEE)
AC Power Cord
AC Power Cord
Literature Bag
AAX8022
Not used
ADG7061
Not used
Not used
Not used
ARW7322
ADG7062
Not used
Not used
Not used
Not used
ADG7076
ADG7104
AHG1180
8 Caution Card
(SD SB)
9 Caution Card
(SB)
10 Caution Card 220-240
11 Warranty Card
(EL)
12 Warranty Card
(EU)
Not used
Not used
ARM7063
Not used
Not used
ARM7064
Not used
ARY7007
Not used
Not used
PRM1078
Not used
Not used
ARY7065
Not used
PRB1315
Not used
Not used
Not used
PRD1071
Not used
Mark No.
NSP
>
>
NSP
NSP
NSP
1
2
3
4
7
Symbol and Description
13 Operating Instructions
(English)
14 Operating Instructions
(English, French, German, Italian, Dutch, Spanish)
15 Operating Instructions
(English, Chinese)
19 Packing Case
20 Remote Control Unit
Not used
Not used
PRD1072
PHG2452
PWW1175
PHG2451
PWW1175
PHG2454
PWW1176
21 Battery Cover
AZN8024
AZN8024
AZN8025
C
D
E
F
9
PD-D6-J
5
6
7
8
1
2
3
4
A
40
49
CONTACT SIDE
NON-CONTACT
SIDE
2.2 EXTERIOR SECTION
43
41
35
28
PD-D6-S/RLFPWXJ
51 Only
52
PD-D6-S/RLFPWXJ
Only
19
39
27
46
B
PD-D6-J/KUXJ/CA
PD-D6-S/RLFPWXJ PD-D6-S/
Only
RLFPWXJ
Only
36
16
J
6
14
41
34
15
D
43
45
40
46
33
27
I
5
37
C
D
43
E
A
40
22
F
Refer to
"2.4 05 LOADER ASSY".
2
E
C
25
32
39
C
20
7
3
47
31
M
D
18
44
43
F
39
F
32
29
46
11
20
H
G
10
46
B
4
46
17
43
I
40
46
8
K
J
L
40
48
23
50
H
M
43
22
21
26
PD-D6-S
/RLFPWXJ
Only
24
44
E
H
30
44
1 9
12
C
E
L
B
A
42
I
44
43
K
13
J
B
G
Refer to
"2.3 FRONT PANEL SECTION".
38
F
42
43
10
PD-D6-J
1
2
3
4
5
6
7
8
(1) EXTERIOR SECTION PARTS LIST
Mark No.
1
2
3
4
5
Description
DVDM ASSY
MNSW ASSY
PLED ASSY
CONNECTOR ASSY
PRIMARY ASSY
6
7
NSP 8
9
10
11
12
NSP 13
> 14
> 15
> 16
NSP 17
18
19
20
TRANS ASSY
AJKB ASSY
Cord With Plug
17P FFC
29P FFC
15P FFC
Connector ASSY
Cord With Plug
Power Transfomer
Fuse 1
Fuse 2
05 LOADER ASSY
Shield Cusion
SR Sheet L
SR Sheet S
Mark No.
Part No.
27
28
29
30
PDD1232
PG05KK-E07
DE005VF0
See Contrast table (2)
See Contrast table (2)
31
NSP 32
NSP 33
NSP 34
35
Power Button ASSY
PCB Angle 989
Label
SISIR Label
Caution Label
See Contrast table (2)
VNE2409
VRW1629
See Contrast table (2)
See Contrast table (2)
36
NSP 37
38
39
40
Fuse Label
Binder
Tray Panel
Screw
Screw
See Contrast table (2)
ZCA-BK1
See Contrast table (2)
ABA1192
ABA7017
41
42
Deco. Screw 4X10
Screw
See Contrast table (2)
BBT30P080FNI
43
44
45
Screw
Screw
Screw
BBZ30P080FCC
BPZ30P080FTC
CBZ30P080FCC
46
47
48
49
Screw
Screw
Washer
Washer
IBZ30P060FCC
VBA1094
PEC1046
WG40FCC
50
51
52
Spacer
Washer
Washer
See Contrast table (2)
See Contrast table (2)
See Contrast table (2)
See Contrast table (2)
VWT1230
AEB7372
PEB1319
PEB1320
NSP 21
22
23
24
25
Flatcable Clamp
PCB Spacer KGPS-12S
Adapter05 L
Adapter05 R
Side Clamp
AEC7376
AEC7517
ANW7282
ANW7283
DEC2007
NSP 26
Chassis
PNA2602
Part No.
See Contrast table (2)
See Contrast table (2)
PNW2029
See Contrast table (2)
AWM8069
AWX8794
AWX8795
AWX8796
See Contrast table (2)
See Contrast table (2)
AWM8075
ADH7022
PDD1230
PDD1231
Description
Rear Panel
Bonnet
PCB Holder
Insulater
>
>
>
NSP
NSP
5
6
14
15
Symbol and Description
PRIMARY ASSY
TRANS ASSY
Power Transfomer
Fuse 1
PD-D6-J/
KUXJ/CA
PD-D6-J/
MYXJ5
PD-D6-S/
RLFPWXJ
AWX8800
AWX8802
PTT1369
REK1058
(1.25 A/ 250 V)
AWX8799
AWX8802
PTT1368
REK1134
AWX8801
AWX8797
PTT1370
REK1023
Fuse 2 (T500 mA / 250 V)
Rear Panel
Bonnet
Insulater
Power Button ASSY
Not used
PNA2606
PNA2610
PNW2766
PXA1644
Not used
PNA2605
PNA2610
AMR7198
PXA1644
REK1134
PNA2607
PNA2603
PNW2766
VXA2724
34
35
36
38
41
SISIR Label
Caution Label
Fuse Label
Tray Panel
Deco. Screw 4X10
Not used
VRW2257
XAX3161
PNW3048
ABA7136
Not used
VRW2257
Not used
PNW3051
ABA7136
PRW1601
VRW2159
XAX3161
PNW3044
ABA7135
Not used
Not used
Not used
Not used
PEC1049
PEC1048
Not used
Not used
WB40FTC
E
F
11
PD-D6-J
5
6
D
(T500 mA/ 250 V) (T1.25 A / 250 V)
16
27
28
30
31
50 Spacer
51 Washer
52 Washer
B
C
(2) CONTRAST TABLE
PD-D6-J/KUXJ/CA, PD-D6-J/MYXJ5 and PD-D6-S/RLFPWXJ are constructed the same except for the following :
Mark No.
A
7
8
1
2
3
4
2.3 FRONT PANEL SECTION
A
Refer to
"2.2 EXTERIOR
SECTION. A "
B
Refer to
"2.2 EXTERIOR
SECTION. C "
18
4
1
16
8
9
D
17
C
Refer to
"2.2 EXTERIOR
SECTION. B "
17
15
3
G
18
10
6
2
5
14
12: 1/2
D
11
7
E
CONTACT SIDE
12: 2/2
NON-CONTACT
SIDE
13
F
12
PD-D6-J
1
2
3
4
5
6
7
8
(1) FRONT PANEL SECTION PARTS LIST
Part No.
Mark No.
LCD ASSY
KEY ASSY
15P FFC
17P FFC
D.Window
AWX8790
AWX8792
PDD1229
PDD1233
PAM1866
11
NSP 12
13
14
15
Lens
Panel ASSY
Tray Panel
Panel Stay
Pioneer Badge
See Contrast table (2)
See Contrast table (2)
See Contrast table (2)
See Contrast table (2)
VAM1124
AL Panel L
AL Panel R
Himelon Sheet
Earth Plate
Earth Plate C
See Contrast table (2)
See Contrast table (2)
PEB1321
PNB1662
PNB1664
NSP 16
17
18
LED Lens
Screw
Screw
VNK5073
BBZ30P080FCC
BPZ30P080FTC
Mark No.
1
2
3
4
5
NSP 6
NSP 7
8
9
10
Description
Description
Part No.
A
B
(2) CONTRAST TABLE
PD-D6-J/KUXJ/CA, PD-D6-J/MYXJ5 and PD-D6-S/RLFPWXJ are constructed the same except for the following :
Mark No.
NSP
NSP
NSP
6
7
11
12
13
Symbol and Description
AL Panel L
AL Panel R
Lens
Panel ASSY
Tray Panel
14 Panel Stay
PD-D6-J/
KUXJ/CA
PD-D6-J/
MYXJ5
PD-D6-S/
RLFPWXJ
PAN1389
PAN1390
PNW3047
PXA1645
PNW3048
PAN1389
PAN1391
PNW3047
PXA1646
PNW3051
PAN1385
PAN1386
AAK7586
PXA1647
PNW3044
PNW3049
PNW3049
PNW3043
C
D
E
F
13
PD-D6-J
5
6
7
8
1
2
3
4
2.4 05 LOADER ASSY
Pickup leneses
Cleaning liquid
GEM1004
Cleaning paper
GED-008
Note :
Refer to
" Application of Lubricant".
A
8
2
Refer to
"2.5 Traverse Mechanism Assy-S".
6
8
8
To DVDM CN101 (Pickup)
To DVDM CN104 (Stepping Motor)
Daifree
GEM1036
To DVDM CN102 (Spindle Motor)
8
B
18
12
Lubricating Oil
GYA1001
24
3
20
13
A
23
22
17
16
19
22
C
21
15
22
To
DVDM CN103
7
A
10
14
11
D
A
9
Lubricating Oil
GYA1001
1
22
05 LOADER ASSY PARTS LIST
Mark No.
E
Mark No.
Part No.
LOAB Assy
Traverse Mechanism Assy-S
Loading Motor Assy
• • • • •
• • • • •
VWG2346
DXX2581
VXX2912
16
17
18
19
20
6
7
8
9
10
Flexible Cable (24P)
Connector Assy 2P
Floating Rubber
Belt
Stabilizer
ADD7546
VKP2253
VEB1351
VEB1358
VNE2253
21
22
23
24
11
12
13
14
15
Loading Base
Float Base 04
Drive Cam
Gear Pulley
Loading Gear
VNL1917
VNL1968
VNL1919
VNL1921
VNL1922
NSP 1
2
3
4
5
F
Description
14
Description
Part No.
Drive Gear
SW Lever
Clamper Plate 04
Bridge 04
Clamper 04
VNL1923
VNL1925
VNE2342
VNE2343
VNL1969
Screw
Screw
Tray
Clamp Magnet
JGZ17P028FTC
VBA1094
VNL1920
VMG1029
PD-D6-J
1
2
3
4
5
6
7
8
Application of Lubricant
A
Lubricating Oil
GYA1001
Around the shaft
No. 11
Loading Base
B
Lubricating Oil
GYA1001
Lubricating Oil
GYA1001
Lubricating Oil
GYA1001
Lubricating Oil
GYA1001
Inner side of a ditch
No. 13
Drive Cam
Lubricating Oil
GYA1001
Inner side of a ditch
C
No. 13
Drive Cam
Lubricating Oil
GYA1001
Front View
Rear View
D
Daifree
GEM1036
Concave of unevenness
No. 23
Tray
Daifree
GEM1036
Concave of unevenness
No. 23
Tray
Inner side of a ditch
E
Daifree
GEM1036
Top View
Bottom View
Concave of unevenness
Side of the rib
Daifree
GEM1036
Daifree
GEM1036
F
15
PD-D6-J
5
6
7
8
1
2
3
4
2.5 TRAVERSE MECHANISM ASSY-S
Note :
1
Refer to
" Application of Lubricant".
A
2
Note : When part #2 is replaced,
part #13 also need to be
replaced at the same time.
4
3
5
B
10
6
9
10
11
Silicone Adhesive
GEM1037
To DVDM CN102
(Spindle Motor)
To
DVDM CN101
(Pickup Assy)
11
C
12
7
To
DVDM CN104
(Stepping Motor)
CONTACT SIDE
NON-CONTACT
SIDE
D
8
Note : Spindle screw (DBA1252) of No.13 is the screw which applied special bond.
Therefore the adhesion becomes ineffective when takes it off once. Spindle screw is the part which cannot recycle.
13
When part #2 is replaced, part #13 also need to be replaced at the same time.
E
F
16
PD-D6-J
1
2
3
4
5
6
7
8
TRAVERSE MECHANISM ASSY-S PARTS LIST
Mark No.
>
Description
Part No.
1
2
NSP 3
NSP 4
NSP 5
05SD Pickup Assy-s
Spindle Motor N200
Guide Shaft VK1
Sub Guide Shaft VK1
Joint VK1B
OXX8019
DXM1197
DLA1940
DLA1941
DNK4272
NSP 6
7
NSP 8
9
10
Joint Spring VK1
Stepping Motor VK1
Mechanism Frame VK1
Precision Screw VK1
Skew Screw VK1
DBK1235
DXM1201
DNK4160
DBA1209
DBA1211
11
NSP 12
13
Skew Spring VK1
DBH1516
Stepping Screw
DBA1205
Spindle Screw VK1(for Service) DBA1252
A
B
C
D
E
F
17
PD-D6-J
5
6
7
8
1
2
3
4
3. BLOCK DIAGRAM AND SCHEMATIC DIAGRAM
3.1 BLOCK DIAGRAM
A
B
DVDM ASSY
IC203
IC204
S-24CS04AFJ
S29AL016D70TFI010-K
EEPROM
4k
B
TRAVERSE
IC202
PGM FLASH
MEMORY
16M
K4S641632K-UC75
64M SDRAM
05 PICK
UP
CN953
IC201
CN101
SPDL
MOTOR
PU
STEPPING
MOTOR
MT1389EE/B2-L
217
6
MAIN DECODER
(CD,SACD)
215
2
6
41 42
225
X202
ASS7075
(27MHz)
CN103
Clock OSC
9
10
IC101
CN102
C
BD7995EFS
IC205
SERVO
DRIVER
TC7SH08FUS1
ASPDIF
CN901
DOUT
20
CN104
SPDIF RQ
LOADING
MOTOR
G
D
D
KEY ASSY
S2301,S2302
J2104A
LCD ASSY
J2104
IC2101
KEY
1
18
1
PDC148A
SYSTEM
CONTROL
CPU
90
7
41
5
2401
GP1UM28XK0VF
LCD Display
IR
E
F
18
PD-D6-J
1
2
3
4
5
5
6
7
8
A
C
AJKB ASSY
14
L/R (DSD)
CN1501
IC1501
L/R (PCM)
6
1
PD0274A
TC74VHC157FTS1
5
PCM/DSD
SEL Lch
MCLK
IC1102(1/2)
JA1101
L
PCM1738EG-3 25
7
26
192k,24bit,
DAC Lch
5
LPF
I/V
IC1401
6
6
IC1602
TC74VHC157FTS1
PCM/DSD
SEL Rch
5
7
PCM1738EG-3
25
26
192k,24bit,
DAC Rch
16
17
5
B
16
17
24
AQE
2
IC1101
IC1301
IC1601
6
IC1201
IC1102(2/2)
JA1201
R
14
H
CONNECTOR ASSY
CN2702
CN2701
DOUT
DOUT
10
13
JA1702
OPTICAL OUT
DOUT
JA1701
COAXIAL OUT
C
SPDIF_RQ
CN2703
5
11
CN2106
CN2105
SRIN
SROUT
2
2
1
1
SYSPOW
JA1751
SR-OUT
CN1502
SRIN
D
JA1752
SR-IN
SROUT
SYSPOW
16
16
J2102
2
LED2
10.8V
8.3V
I
2
CN2503
CN2501
2
1
1
6.5V
PRIMARY ASSY
5.8V
J11
J13
2
F
POWER
SUPPLY
5V
3.3V
1
1
CN1503
E
CN1801
MNSW ASSY
CN2502
2
J52
PLED
25
3
CN1851
CN13
J12
AC IN
2
J51
1
J2601
E
T51
J
PLED ASSY
TRANS ASSY
SW11
Voltage Selector
F
PD-D6-S ONLY
19
PD-D6-J
5
6
7
8
1
2
3
4
LOW
AC CORD
PF04PG-C07
B4B-PH-K-S
J11
SW11
SR-IN
AKX1033
HIGH
SR-OUT
PRIMARY ASSY
(PD-D6-J/KUXJ:AWX8800)
(PD-D6-J/MYXJ5:AWX8799)
(PD-D6-S/RLFPWXJ:AWX8801)
JA1752
RKN1004
I
WY : ADG7062
KU : ADG7061
RD : ADG7076
ADG7104
A
JA1751
RKN1004
3.2 LOAB ASSY and OVERALL WIRING CONNECTION DIAGRAM
CN1503
L=75mm
1
2
3
4
1
2
3
4
SYSPOW
AC
V+56ST
GNDU
CN1801
B7B-EH
AC INLET
PKP1014
PD-D6-J
ONLY W124
W129
J12
AUDIO CT
AUDIO1
AUDIO2
DIGITAL1
DIGITAL2
MECHA1
MECHA2
PD-D6-S
ONLY
FU1
1
B
2
7
6
5
4
3
2
1
J13
PKP1015
RY11
1
2
B2P3-VH
1 2
1 2 3
PD-D6-J ONLY
CKS3382
GNDU
GNDU
AC
SYSPOW
XDACRST
SROUT
SRIN
GNDD
GNDD
XDFDT
XDFCLK
XDFCS
XDFRST
XSYSMUTE
V+56ST
GNDD
V+58U
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
CN1502
B3P5-VH
VL
HOT(VH)
NEUTRAL
CN13
C
J51
PD-D6-S ONLY
3
2
J
2
1
1
PKP1016
PKP1018
PD-D6-J ONLY
PDD1233
L=300mm
P=1.25mm
FFC
VKN2024
4
3
2
1
CN2501
TRKG DRV
TRKG RTN
FOCS DRV
FOCS RTN
1
2
3
4
STEPPING MOTOR
S2301
(Mechanical
Power SW)
V+5U
GNDD
L=120mm
1
2
3
4
IROUT
SRIN
GNDD
GNDD
XDFDT
XDFCLK
XDFCS
XDFRST
XSYSMUTE
V+56ST
GNDD
V+58U
GNDU
GNDU
AC
SYSPOW
XDACRST
MSDCT
LED2
CN2101
52492-0720
CN2105
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
1
2
3
4
7
6
5
4
3
2
1
CN2503
E
N.C.
VSS
VCC
RST
WCLK
WD0
WEN/DI
B4B-PH-K-S
9607S-17F
J2102
PF04PG-C12
2
1
CN2502
V+5U
1
L=75mm
PLED
2
S2B-PH-K-S
PF02PG-C07
J2601
VOUT
V+5U
GNDD
IR
W136
W137
W138
F
E
PLED ASSY
(AWX8795)
20
PD-D6-J
1
2
3
21
22
23
24
ST2-(B)
ST2+(B)
ST1+(A)
ST1-(A)
MNSW ASSY
(AWX8794)
SPINDLE MOTOR
FFC
P=1.0mm
J52
PKP1017
1
2
3
4
1
2
RKN1045
CN103
12
11
10
9
8
7
6
5
4
3
2
1
F
AKN7031
CN102
INSIDE
W
V
U
HB
WW+
VV+
UU+
V+5S
D
AUDIO CT
AUDIO1
AUDIO2
DIGITAL1
DIGITAL2
MECHA1
MECHA2
FFC
P=1.0mm
Power
Transformer
WY : PTT1368
PD-D6-J KU : PTT1369
PD-D6-S RD : PTT1370
7
6
5
4
3
2
1
1
2
3
4
5
6
7
8
9
10
11
12
TRANS ASSY
(PD-D6-J:AWX8802)
(PD-D6-S:AWX8797)
4
8
COAX-OUT
7
A
VKB1097
JA1701
OPT-OUT
JA1702
VKS1002
(TOTX147L)
Rch OUT
PKB1042
JA1201
PKB1041
6
CN1851
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
JA1101
Lch OUT
5
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
AJKB ASSY
(AWM8075)
V+12A
V+9D
V+9D
GNDD
GNDD
V+6R5V
V+6R5V
GNDM
GNDM
GNDD
DVDMUTE
GNDD
DOUT
GNDD
GNDD
FFC
P=1.25mm
L=125mm
PDD1232
C C 1/2, C 2/2
CKS3380
CN2702
CKS3380
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
FFC
P=1.0mm
L=120mm
PDD1230
CKS3885
B B 1/2, B 2/2
DVDM ASSY
(AWM8069)
CN104
CKS5045
AKM1291
PG05KK-E07
L=75mm
LOADLOAD+
SW2
GNDD
SW1
FFC
P=0.5mm
L=220mm
ADD7546
GNDD
F
VREF
VCC
E
D
C
SW
RF
B
A
VR650
VRCOM
VR780
GNDD
LD(780)
PD
LD(650)
GNDD
VSHF
C
CN2704
B2P-SHF-1AA
PDD1231
L=100mm
P=1.0mm
FFC
CN2703
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
CN602
LOAB ASSY
(VWG2346)
VKN1191
D
GNDD
DVDPOWER
XREADY
XDVDRST
SDATA
SCLK
ACK
MDATA
GNDD
GNDD
SPDIFP_RQ
VDET
TRIN
TRGAIN
TROUT
2
1
LOADING
MOTOR
ASSY
: VXX2912
FFC
P=1.0mm
L=285mm
PDD1229
LOAD-
SW2
LOAD+
SW1
V+3D
S5B-PH-K-S
CN601
A
CONNECTOR ASSY
(AWX8796)
H
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
1
2
3
4
5
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
MECHA ASSY
(AWM7967)
1
2
3
4
5
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
PICKUP ASSY
B
2 CVBS
1 GNDD
CN101
29
28
27
26
25
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
VKN1205
XPCM/DSD
GNDD
XDACCS2
XDACCS1
XDACCK
XDACDT
GNDD
BCK
GNDD
DATA1
GNDD
DATA0
GNDD
LRCK
GNDD
MCLK(22M)
GNDD
CN953
CVBS
TROUT
TRIN
TRGAIN
SPDIF_RQ
TRKUP
DVDMUTE
VDET
GNDD
GNDD
ACK
MDATA
SDATA
SCLK
XREADY
XDVDRST
DVDPOWER
GNDD
GNDD
DOUT
GNDD
GNDD
GNDM
GNDM
V+6R5V
V+6R5V
V+9D
V+9D
V+12A
CN2701
VKN1248
VKN1321
CN901
CN1501
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
CN2106
CKS3829
E
P=2.0mm
L=200mm
D
1
2
3
LCD ASSY
(AWX8790)
J2104
KEY1
VE+5
GNDD
D20PYY0320E
1
2
3
J2104A
÷ When ordering service parts, be sure to refer to "EXPLODED VIEWS and PARTS LIST" or
"PCB PARTS LIST".
÷ The > mark found on some component parts indicates the importance of the safety factor
of the part. Therefore, when replacing, be sure to use parts of identical designation.
÷
: The power supply is shown with the marked box.
G
KEY ASSY
(AWX8792)
F
21
PD-D6-J
5
6
7
8
1
2
3
4
3.3 DVDM ASSY (1/2)
B 1/2
DVDM ASSY
(AWM8069)
IOA
A
R301
0
V+5S
IOA
R373
***
V+3R3
R372
A 11
R371
VR650 12
VRCOM 13
***
B
R313
100K
A
***
R303
0
MDI1
R200
GNDD
R318
Q308
HN1A01F(YGR)
(1/2)
100K
GNDD 15
L309
***
LD(780) 16
1
4
2
5
6
GNDD
LDO1
3
D
A
B
C
RF
PD 17
FOCS RTN 24
4.7
4
2
5
6
(RF)
LDO2
3
F+
Q307
HN1A01F(YGR)
(2/2)
F-
R302
0
GNDD
C309
R325
T-
1
E
F
MDI1
GNDD
4
CN102
C143 ***
V
W
C161
1000p
TRIN
LOADLOAD+
F+
F-
GNDD 4
(S)
(S)
E
C132 100/16
VCH1252-
C218
0
C216
0.1
***
10K
10K
***
***
C217
0.1
A18
A19
1
R141
(F)
(T)
TROPEN
120k
C219
1500p
R216
FOSO
0
TRSO
V+3R3
B 2/2
22k
180k
220k
A2
A3
A4
A5
A6
A7
A8
1
V+5M
Q101
2SA1576A(RS)
V+3D
R208
R142
B 2/2
1.5K
22K
R204
R205
R206
***
R215
R213
R212
R211
R210
0
C290
TROUT
R201
R202
1.8v
3.3v
(S)
(S)
Q201
***
GNDD
TRIN
C214
0.1
C206
47/16
R214
C121
TROUT
SW1 5
C213
0.1
C221
***
LOAD+
0.1
E
FG
TROUT
TRIN
STBY
ENDM
22k
LOAD+ 2
C205
C
B
FMSO
ST1+
ST1ST2+
ST2-
LOAD-
(F)
AKM1291
(side type)
LOAD- 1
SW2 3
LDOP
LDON
FCO+
FCOTKO+
TKOAVM
AGND
TKIN
FCIN
LDIN
DVCC
SLVDD
SLO1P
SLO1N
SLGND
SLO2P
SLO2N
SLIN2
SLIN1
SLRNF2
SLRNF1
(F) 0.01
CN104
0.1
(T)
(F)
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
C101
ST1-
C204
C208
2200p
C210
2200p
C211
56p
DMSO
FMSO
TROPEN
PWMOUT1
TRSO
FOSO
PWMOUT1
(T)
4
YB
C151
0.01 YB
ST1-(~A~)
GNDM
ST1+
(T) 0.01
3
ST2ST2+
SERVO DRIVER
BD7995EFS
T+
T-
ST1+(A)
(S)
(S)
(S)
(S)
C153
YB
C152
2
C133
***
(side type)
100/16
4.7
4.7
4.7
4.7
4.7
R136 4.7
R131
R132
R133
R134
R135
CN103
RKN1045
C131 0.1
IC101
GNDD
1
V+6R5
1
C104
C140
R153
1
C102
1
V+5S 12
1
V1P4
HU-
V+5S
ST2+(B)
U
HU+
HUHV+
HVHW+
HW-
HV+
HU+
U+ 11
ST2-(~B~)
DMSO
R154
1.8
9
HV-
C146
2200p
V+
HW+
C145
2200p
8
V20
V1P4
STBY
R151
1
7
V-
HW-
R152
1.8
W+
ENDM
2200p
6
C144
5
1
4
W-
C215
47/16
C203
47/16
FG
V
U
C103
U
HB
W
C142 ***
3
C141 ***
2
V
44
43
42
41
40
39
38
37
36
35
34
33
32
31
30
29
28
27
26
25
24
23
W
C207
0.1
LDO2
LDO1
LIMIT
U- 10
A
D
1
VCC
HU+
HUHV+
HVHW+
HWHB
SPGND1
U
SPVM1
V
SPGND2
SPVM1
W
SPRNF
FG
CTL1
CTL2
SPIN
DGND
VC
CN601 STEPPING MOTOR SPINDLE MOTOR
AKN7031
(side type)
INSIDE
1
1
1
1
1
C343
C346
C345
C344
C347
3.3v
TRKG RTN 22
FOCS DRV 23
Q307
HN1A01F(YGR)
(1/2)
T+
47/35
VCH1260
(T)
(T)
(F)
(F)
TRKG DRV 21
4.7
L308
***
VSHF 20
R322
LD(650) 18
GNDD 19
0
0
Q308
HN1A01F(YGR)
(2/2)
R315
10K
3
2
1
5
R207
V+3R3
Q304
2SC4081(QR)
Q305
UM5K1N
4
VR780 14
V+3RF
C201
220/4
RF
(RF)
B 10
C
V+1R8BE
C202
220/4
***
V+1R8
V+5S
C212
56p
9
R374
E
TRGAIN
SCL
Q102
DTC124EUA
R219 10K
RF
C
D
R218 10K
8
***
C209
0.1
7
0.1
STBY
C
SW
C371
R375
R310
***
6
C320
5
47/35
VCH1260
4
E
D
F
0.1
R321
VCC
C372
4.7
3
C310
VREF
C374 VCH1260
(47/35)
C373 VCH1260
(47/35)
R326
2
4.7
B
1
F
R314
10K
PICKUP ASSY
(side type)
GNDD
V20
GNDD GNDD
CN101
CKS5045
SDA
8
VCC
7
WP
6
SCL
5
SDA
0.1
IC204
EEPROM
1
NC
2
NC
3
NC
4
GND
S-24CS04AFJ
(AD)
R284
10k
AD2
AD3
AD4
AD5
AD6
A0
AD7
A17
A16
~BYTE~
VSS
D15
D7
D14
D6
D13
D5
D12
D4
VCC
D11
D3
D10
D2
D9
48
47
46
45
44
43
42
41
40
39
38
37
36
35
34
33
32
V+3D
AWY7119
A15
A14
A13
A12
A11
A10
A9
A8
A19
NC
~WE~
~RESET~
NC
NC
RY/~BY~
A18
A17
(D)
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
(S)
GNDD
IC203
(T)
: RF SIGNAL ROUTE
: FOCUS SERVO LOOP LINE
: TRACKING SERVO LOOP LINE
: STEPPING SERVO LOOP LINE
: DIGITAL SIGNAL ROUTE
: AUDIO DATA SIGNAL ROUTE
FLASH
S29AL016D70TFI010-K
(F)
1
C296
for ICE MODE
(RF)
1000p
C289
V+3D
R282
***
IOWR#
IOCE#
ALE
UWR#
URD#
UP3_1
INT0#
GNDD
F
B 1/2
22
PD-D6-J
1
2
3
4
A19
A18
PWR#
A16
A15
A14
A13
A12
A11
A10
A9
A20
PWR#
GNDD
PCE#
R285
***
5
6
7
8
DAC_XCS1
XAMUTE
DAC_XCS0
DAC_SCK
DAC_SO
ACLK
ABCK
ALRCK
ASDAT0
S_Y
C247
***
0.01
R279
560F
R280
***
188
187
C244 0.1
186
185
184
C236 0.1
183
182
180
179
R265
R264
R263
***
***
***
R262
***
VSEL2
VSEL1
LETTER
177
176
175
R267
0
V+3D
R281
178
SQUEEZE
174
173
V+3DR
0
181
172
C235 0.1
169
C281
220/4
I/XP
170
R266
33
C
1
171
C283
0.1
167
166
C234
0.1
MA4
MA5
MA6
165
164
163
162
MA7
161
160
159
158
157
156
C233
0.1
R229
R228
33
***
MA8
MA9
MA11
SDCKE
SDCLK
DQM1
155
154
153
MA4
MA5
MA6
MA7
MA8
MA9
MA11
C232
0.1
C284
DQ8
152
MA3
MA2
MA1
151
150
149
0.1
DQ9
DQ10
148
147
146
R227
145
33
MA0
MA10
DBA1
144
143
142
C231
0.1
R226
33
DBA0
DQ11
DQ12
DQ13
DQ14
C285
141
140
R225
33*4
RAB4C330J
139
138
137
DCS#
DRAS#
DCAS#
DWE#
DQM1
DQ15
0.1
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
VSS
A4
A5
A6
A7
A8
A9
A11
NC
CKE
CLK
UDQM
NC
VSS
DQ8
VCCQ
DQ9
DQ10
VSSQ
DQ11
DQ12
VCCQ
DQ13
DQ14
VSSQ
DQ15
VSS
IC202
168
DQ0
C288
0.1
DQ1
DQ2
DQ3
DQ4
C287
0.1
DQ5
DQ6
D
DQ7
C286
0.1
GNDD
134
DQ9
DQ10
DQ11
DQ12
DQ13
133
132
131
130
129
STBY
***
R603
***
***
R601
R602
***
V+5V
33
33
33
33
33
33
33
33
R221
R237
R234
R258
R259
R260
R261
MA3
MA2
MA1
MA0
MA10
DBA1
DBA0
DCS#
DRAS#
DCAS#
DWE#
DQM0
R223
DQ14
DQ2
DQ1
DQ0
DQ15
DQ4
DQ3
GNDD
INT0#
DQ6
DQ5
DQM0
GNDD
DQ7
RXD
TXD
UP3_1
SCL
SDA
UWR#
URD#
A17
A0
ALE
AD7
AD4
AD5
AD6
A1
PRD#
IOCE#
AD0
AD1
AD2
AD3
A10
A9
A20
PCE#
R233
0
33
27
26
25
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
DQ8
135
3.3v
1.8v
R224
VCC
A3
A2
A1
A0
A10/AP
BA1
BA0
CS
RAS
CAS
WE
LDQM
VCC
DQ7
VSSQ
DQ6
DQ5
VCCQ
DQ4
DQ3
VSSQ
DQ2
DQ1
VCCQ
DQ0
VCC
136
E
Chip Size
A1
PCE#
A16
A15
A14
A13
A12
A11
R232
0
189
C230
1000p
***
R239
C228
0.1
***
R236
0.01
R220 ***
C226
C225 0.1
C227 220p
R235
4.7k
C224
0.1
C223
0.1
C222
0.1
R217 0
C220
0.1
IOWR#
PWR#
AD0
PRD#
C243
1
190
128
127
126
125
124
123
122
121
120
119
118
117
116
115
114
113
112
111
110
109
108
107
106
105
104
103
102
99
101
98
100
97
96
95
94
93
92
91
90
89
88
87
86
85
84
83
82
81
80
79
78
77
76
75
74
73
72
71
70
69
68
67
66
65
3.3v
1.8v
AD1
C242
***
191
R604
HIGHA6(PU)
65:APLLVSSVDD3
HIGHA5(PU)
66:XIOWR
HIGHA4(PU)
67:A16
HIGHA3(PU)
68:HIGHA7(PU)
DVDD3
HIGHA2(PU)
HIGHA1(PU)
IOA20
XIOCS (PU)
IOCA1 (PU)
XIOOE
DVDD3
AD0
AD1
AD2
AD3
DVSS (18)
AD4
AD5
AD6
IOA2/V_ADIN0
ALE (PU)
AD7
A17
IOA0 (PU)
DVSS (3)
XUWR (PU)
XURD (PU)
DVDD18
UP1_2 (PU)
UP1_3 (PU)
UP1_4 (PU)
UP1_5 (PU)
UP1_6 (PU)
UP1_7 (PU)
UP3_0 (PU)
UP3_1 (PU)
UP3_4 (PU)
UP3_5 (PU)
DVDD3
ICE (PD)
XPRST (PU)
IR
XINT0 (PU)
DQM0
DQS0
RD7
DVSS (18)
RD6
RD5
DVSS (3)
RD4
RD3
DVDD18
126:RD15
RD2
127:DVDD3
RD1
128:RD14
RD0
2
GNDD
192
64M SD-RAM
K4S641632K-UC75
3
B
3.3v
1.8v
MT1389EE/B2-L
0
C237
220/4
C250
C245 0.1
C246 0.1
C239 0.1
R238 10k
C240 0.1
C248
R247 10K
***
R249 10K
C241
0.1
CEQN
CEQP
RFGND
CRTPLP
HRFZC
RFRPAC
RFRPDC
RFVDD3
S_VREFN
S_VREFP
ADCVSS
S_VCM
ADCVDD3
LPFOP
LPFIN
LPFIP
LPFON
PLLVDD3
IDACEXLP
PLLVSS
JITFN
JITFO
XTALI
XTALO
RFVDD18
RFGND18
SPDIF
MC_DATA
(3) DVSS
(PD) ASDATA4
DVDD18
(PD) ASDATA3
(PD) ASDATA2
(PD) ASDATA1
(PD) ASDATA0
(18) DVSS
ACLK
ABCK
(PD) ALRCK
DVDD3
SPBCK/ADATA5
SPLRCK
SPDATA
SPMCLK
HSYN/V_ADIN2
YUV7/ASDATA5
VSYN/V_ADIN1
DVDD3
YUV6/R
YUV5/B
DACVSSA
YUV4/G
DACVDDA
YUV3/CVBS
DACVSSB
YUV2/C
DACVDDB
YUV1/Y
DACVSSC
AVDD3:256
IREF:255
RFGC:254
OSN:253
OSP:252
IC201
V+3R3
R209
C282
S_C
CVBS
G_CY
R_CR
B_CB
100
100
100
100
1k
R270
R269
(AD)
R243
R242
R241
10
33
33
33
***
33
33
DSD_Rch
R246
R245
R244
R257
0
C253
0.1
C257
0.1
C258
0.047
C259
0.047
C260
0.1
0.1
C261
1
R272
33
R253
***
R252
***
(D)
C256 10/16
C255 0.47
C262
0.1
C264
0.1
22p
R255
100K
C267 C265
1000p
C268
0.1
C266
C270
STBY
C269
0.033
R256
15k
C272
0.1
C271
0.1
0.1
C273
64
(INPUTPU) RD16
(INPUTPU) RD17
(INPUTPU) RD18
(INPUTPU) RD19
(INPUTPU) RD20
(INPUTPU) RD21
DVDD3
RD22
RD23
(INPUT PU) DQM2
(INPUTPU) DQM3
(INPUT) RD24
RD25
(3) DVSS
RD26
DVDD18
RD27
RD28
RD29
(PU) RD30
(PU)RD3/ASDATA5
DVDD3
RA4
RA5
RA6
(18) DVSS
RA7
(3) DVSS
RA8
RA9
RA11
CKE
RCLK
DVDD3
RCLKB
RVREFN_ADIN3
DVDD18
RA3
RA2
RA1
(3) DVSS
RA0
RA10
BA1
(18) DVSS
BA0
XRCS
DVDD3
XRAS
XCAS
XRWE
DQM1
DQS1
RD8
(3)DVSS
RD9
RD10
RD11
RD12
RD13
YUV0/CIN:192
FS:191
VREF:190
DACVDDC:189
5
VIDEO
(Page 2/2)
193
63
194
62
195
61
196
60
197
59
198
58
199
57
200
56
201
55
202
54
203
53
204
52
205
51
206
50
to VIDEO PART
3.3v
1.8v
3.3v
207
49
208
48
209
47
210
46
211
45
212
44
213
43
214
42
215
41
216
40
217
39
218
38
219
37
220
36
221
35
222
34
223
33
224
32
225
31
226
30
227
29
228
28
229
27
230
26
231
25
232
24
233
23
234
22
235
21
236
20
AGND
DVDA
DVDB
DVDC
DVDD
DVDRFIP
DVDRFIN
MA
MB
MC
MD
SA
SB
SC
SD
CDFON
CDFOP
TNI
TPI
MIDI1
MIDI2
LDO2
LDO1
SVDD3
CSO/RFOP
RFLV/RFON
SGND
V2REFO
V2O
VREFO
FEO
TEO
TEZISILV
OP_OUT
OP_INN
OP_INP
DMO
FMO
TROPENPWM
PWMOUT1/V_ADIN9
TRO
FOO
USB_VSS
USBP
USBM
USB_VDD3
FG/V_ADIN8 (PU)
TDI/V_ADIN4 (JTAG)
TMS/V_ADIN5 (JTAG)
TCK/V_ADIN6 (JTAG)
TDO/V_ADIN7 (JTAG)
DVDD18
IOA2 (PU)
IOA3 (PU)
IOA4 (PU)
IOA5 (PU)
IOA6 (PU)
IOA7 (PU)
HIGHA0(PU)
IOA18 (PU)
IOA19 (PU)
DVSS
APLLCAP
APLLVSS
AUDIO
B 2/2
DAC
control
V+3V
1.8v
237
19
238
18
239
17
240
16
241
15
C254
390p
R254
750K
242
14
1
243
13
244
12
245
11
246
10
247
9
248
8
249
7
250
6
251
5
252
4
C263
3.3v
1.8v
253
3
254
2
255
256
1
R251
***
R248
100
R271
X201
***
GNDD
V1P4
to AUDIO PART
(Page 2/2)
R268
R231
R230
GNDD
OUT
ASS7075
(27MHz)
(D)
(AD)
***
***
C299
1000p
X202
1 CONT
4
VDD
2 GND
3
C252
C251
0
ASDAT1
ASDAT2
R273
V+3R3
(R203)
L201
0
C298
1
ASPDIF
R240
***
RF
IOA
A
DIODE
1SS355
V+3DR
RESISTOR
R909
***
DOWNLOAD
TRKUP
CN204
XDVDRST
MDATA
SCLK
ACK
SDATA R908
3.3k
LIMIT
XREADY
31
30
29
28
27
26
25
D1
D8
D0
~OE~
VSS
~CE~
A0
:2125 Size
RS1/10S***J
4
3
2
1
6.8k
GNDD
B 2/2
SYS
:1608 Size
(F):RS1/16S****F
OTHERS:RS1/16S***J
CAPACITOR
:2125 Size
CKSQ**~
A7
A6
A5
A4
A3
A2
A1
:1608 Size
A8
A7
A6
A5
A4
A3
A2
18
19
20
21
22
23
24
CH:CCSRCH~
OTHERS:CKSRYB~
F
B 1/2
23
PD-D6-J
5
6
7
8
1
2
3
4
3.4 DVDM ASSY (2/2)
DVDM ASSY
(AWM8069)
VOLTAGE DETECT
GNDD
ASDAT1
V+3R3
12
ASDAT2
0.1
UDZS4.7B
R882
10K
47K
R822
Q801
DTC124EUA
IC591
TC7SHU04FU
C591
1
11
BCLK
GNDD
D821
GNDD
C592
***
10
GNDD
13
B
D801
R823
15K
GNDD
STBY
DATA2
NORMAL : 3.3V
ABNORMAL :
0.5VDD
0.85VDD
VDET
Q821
2SA1576A(RS)
R824
10K
D861
ABCK1
0
GNDD
V+5V
D852
PCM OUT
R595
ASDAT0
D862
4
5
8
6
DATA1
9
GNDD
7
GNDD
DATA0
V+12
V+6R5
ALRCK
V+3R3
C801
GNDD
0
LRCLK
Q851
2SA1576A(RS)
R853
10K
ABCK0
47K
D881
ABCK
R821
2
GNDD
ACLK0
STBY
DAC 2ch
R594
1
MCLK
3
GNDD
STBY
D851
VKN1417
R881
47K
R883
***
R852
10K
R851
CN951
R801
(D)
ASPDIF
VPR+8
V+12
470
from PAGE 1/2
AUDIO
V+5V
V+12
Q881
2SA1576A(RS)
B 1/2
10k
B 2/2
A
ACLK
5
2
R592
4
ACLK0
10
3
ABCK1
(D)
GNDD
R591
GNDD
0
XAMUTE
ZEROL/NA
VCC
ZEROR/ZEROA
VOUTL
VCOM
VOUTR
GNDA
GNDD
R518
1K
GNDD
C511
C512
R511
22K
470
22K
GNDA
Q501
2SD2114K(VW)
R513
R512
C504
0.1
C503
100/16
C502
***
(D)
STBY
GNDA
Q503
DTC114YUA
10/16
0.1
Q504
DTC114YUA
DAC_XCS0
DAC_SCK
DAC_SO
SYS
R519
10K
SI
VDD
22
100
100
100
R514
1000p CH 1000p CH
SCK
GNDD
R506
R507
R508
R509
C513
PCMLRCK
16
15
14
13
12
11
10
9
C514
CS
C508
0.1
C509
10/16
C507
0.1
***
C506
10/16
C505
1
C500
ACLK0
PCMMCK
PCMDATA
R501
0
C501
0
R590
R500
***
V+5V
PCMBCK
2SA1576A(RS)
Q505
STBY
B 1/2
FL
R515
2.2K
R516
2.2K
FR
10/16
Q502
2SD2114K(VW)
470
CN953
CKS3885
D
GNDD
1
MCLK
2
(L931)
R931
ACLK0
CTF1384
GNDD
3
R932
LRCLK
4
GNDD
5
DATA0
6
GNDD
7
DATA1
8
GNDD
9
ALRCK
0
R933
(AD)
ASDAT0
ASDAT1
0
DSD_Rch
0
R934
R935
ABCK1
BCLK 10
0
(L936)
R936
(L937)
R937
(L938)
R938
(L939)
R939
SO 12
SCL 13
XCS0 14
XCS1 15
CTF1389
DAC_SO
CTF1389
DAC_SCK
CTF1389
DAC_XCS0
CTF1389
DAC_XCS1
GNDD 16
R940
DATA2 17
ASDAT2
external DAC control
GNDD 11
0
GNDD
C 1/2
CN1501
E
Chip Size
from PAGE 1/2
VIDEO
DIODE
B 1/2
1SS355
RESISTOR
Size
RS1/10S***J
:1608 Size
(F):RS1/16S****F
OTHERS:RS1/16S***J
F
CAPACITOR
:2125Size
CKSQ**~
:1608 Size
B 2/2
CH:CCSRCH~
OTHERS:CKSRYB~
24
***:parts not mounted
PD-D6-J
1
2
3
to PAGE 1/2
GNDD
B
R502
0
1
2
3
4
5
6
7
8
100
100
100
DVDMUTE
C
C
IC501
PCM1753DBQ
E
R505
R504
R503
ABCK0
Q506
DTC114YUA
R517
1K
V+5V
AUDIO
DAC
(FL,FR)
ASDAT0
ALRCK
V+3R3
R520
1K
V+5V
4
5
6
7
V+12
8
VDVD+12
A
***
C1003
VPR+8
27
VPR+8
26
6R5V
25
6R5V
24
GNDM
23
GNDM
22
GNDD
21
GNDD
20
DOUT
R731
(D)
C731
***
C733
VDVD+12
28
GNDM
R901
0
18 GNDD
D731
R740
GNDD
Sub
IC761
***
5
6
4
R761
***
1
2
3
C762
R762
***
C763
***
C761
100/16
6.5V
GNDM
GNDD
R904
6.8k
R906
6.8k
R916
22K
R919
***
R917
22k
13 SDATA
12 MDATA
9
GNDD
0
8
VDET
DVDMUTE
R913
0
7
DVDMUTE
TRKUP
R914
6
TRKUP
5
SPDIF_RQ
TRGAIN
4
TRGAIN
TRIN
3
TRIN
TROUT
2
TROUT
1
CVBS
10k
R915
R920
R406
75
6.8k
3.3k
0.1
GNDD
5
RGB
V
VSEL2
V+RGB
R481
IC205
TC7SH08FUS1
S
2
1K
VSEL1
0
3
CN952
GNDD
*2
R404
R405
1K
IC401
4
3
2
1
R411
***
R431
***
0.1
C412
1
C413
1
MM1623BF
***
C404
100/16
C405
0.1
GNDD
C414
1
C415
0.1
R404
*2
0.1
C416
1
2
3
4
5
6
7
8
9
10
11
12
13
14
Vcc1
C in
MUTE1
V in
YC MIX
Y in
GND1
BIAS
I/P
CY in
CLP
Cb in
MUTE2
Cr in
Vcc2
DC out
C out
S1
S2
V out
GND2
Y out
CY out
GND2
Cb out
GND2
Cr out
GND2
28
27
26
25
24
23
22
21
20
19
18
17
16
15
C402
0
SQUEEZE
R922
0
VSEL2
R923
0
VSEL1
R924
0
R403
0
R421
0
0.1
C406
SQUEEZE
LETTER
V+5V
1
R423
R424
0
GNDD
8
V
9
0
GNDD
10
SY
11
GNDD
12
CY/G
13
GNDD
14
Cb/B
15
GNDD
16
Cr/R
17
GNDD
18
R
19
GNDD
20
G
21
GNDD
22
B
23
GNDD
24
GNDA
25
FL
26
GNDA
27
FR
***
0
R425
0
D
R426
0
***
C425
10K
R401
R413
***
R433
***
R474
***
***
0
C474
V+5V
R475
***
0
C475
IC451
MM1566AJ
C464
C465
0.1
0.1
B_CB
C466
***
C454
100/16
0.1
R435
***
C455
0.1
1
2
3
4
5
6
7
8
Vcc1
R in
MUTE1
G in
MODE1
B in
BIAS
GND1
Vcc2
R out
MODE2
G out
VSAG
GND2
B out
YSAG
16
15
14
13
12
11
10
9
C452
C451
100/16
R414
***
SC
7
C426
C453
R434
***
ASPECT
6
***
I/XP
GNDD
R415
***
5
C424
Q401
DTC114YUA
GNDD
VSEL1
C423
EXTRA VIDEO OUT
G_CY
4
C422
GNDD
GNDD
SQUEEZE
3
VSEL2
***
GNDD
S_Y
P/XI
2
C421
0.1
R422
R405
*2
R432
***
R412
75
CVBS
VKN1319
R921
GNDD
C403
C411
CN902
Q481
DTC114YUA
V+5V
STBY
CN904 ***
S_C
AKM1288
STBY
I/XP
except
PROGRESSIVE
PROGRESSIVE
STBY
1K
10K
GNDD
C
1
R402
4
1
PROGRESSIVE
V+5V
R250
C401
100/16
2
B
11 ACK
R912
(D)
C249
14 SCLK
VDET
B 1/2
V+3D
15 XREADY
10 GNDD
Cont 5
***
Vin 7
R763 ***
R764 ***
R751
0
D751
V+6R5
C751
1
C753
Vo
NC
GND
Cn
470P
C752
5.0V
1
2
3
4
2.2
C754
***
R750
0
IC751
MM1565AF
R765
1SR154-400
7.8V
17 DVD
POWER
16 XDVDRST
XDVDRST
STBY
L751
CTF1395
V+5S V+5V V+5M
R902
0
R903
3.3k
XREADY
R905
3.3k
L901
SCLK
R907
470
CTF1334
SDATA
R918
***
R910
MDATA
220
R911
ACK
220
0
CN2701
19 GNDD
H
D733
DCH1165
10
C732
C734
100/16
C736
0.1
C735
DCH1165
10
R732 10
R733 22
EXT 4
C1002
L731
DTL1099
22
3 4 5
VIN 5
47k
R701
GNDD
DCH1165
10
D732
RSX201L-30
15K(F)
R735 C737
18K(F)
1 CE
2 GND
3 VOUT
R734
R739
0
2.7K 120P
27K(F)
C738
10
DCH1165
R737 R738
R736
1
***
100/16
C711
C740
C739
C712
470P
***
R714
2.2
***
***
R712 R713
IC731
R1224N102H
1
2
0
R476
***
0
C476
***
0.1
FL
FR
R521
0
R522
0
GNDD
CN905
DAC 2ch
***
1
2
GNDD
GNDD
3
R_CR
R416
***
4
C1001
5
E
GNDA
FR
GNDA
FL
GNDA
***
R436
***
GNDA
GNDD
GNDA
VSEL1
C714
***
C713
GNDD
22
Q702
DTC124EUA
Q731
***
29
***
R711
8
7
6
5
***
Vin
NC
NC
Cont
VKN1321
GNDD
4
Vo
NC
GND
Cn
CN901
***
5
1
2
3
4
L732
ATH7011
VPR+8
10K
6
3
IC711
MM1661JH
R702
2
DC-DC CONVERTER
1
C702
1
V+3R3
V+1R8
***
C701
Q732
RSQ035P03
47K
Q701
2SA1576A(RS)
GNDD
STBY
(D)
(AD)
(C1011)
R1001
CKSQYB104K16
: DIGITAL SIGNAL ROUTE
R1002
: AUDIO DATA SIGNAL ROUTE
***
R1003
***
GNDD2
F
GNDD
B 2/2
25
PD-D6-J
5
6
7
8
1
2
3
4
3.5 AJKB ASSY (1/2)
V+3D
AJKB ASSY
(AWM8075)
1
B
GNDD 1
C1508
1
2
R1515
68
MCLK(22M) 2
*
C1507
22
DALOUT
LRIN
DAROUT
BCKIN
LROUT
RSTB
BCKOUT
CGND
CGND
XIN
IGND
OGND
OVDD
ICVDD
NC6
SCKL
NC5
SDATA
NC4
CSB
NC3
NC1
NC2
R1503
24
23
22
21
20
19
18
17
16
15
14
13
(AD)
(AD)
22
R1504
22
3
4
R1505
22
C1504
1 YF
(AD)
GNDD
(AD)
GNDD 3
DAIN
0.01
R1502
1
R1552
2
22
3
R155122 4
C1502
5
0.1
6
C1503
7
1 YF
8
9
10
11
12
*
C1506
1
VKN1248-
R1501
IC1501
PD0274A
R155322
(AD)
CN1501
C1501
4 :LEGATO:OFF
330/6.3
4.7
VCH1248 (2125)
C 1/2
3
4
3
4
3 :LEGATO:ON
AQE
A
R1507
68
LRCK 4
GNDD 5
R1508
68
R1509
DATA1 8
68
1 2
C 2/2
R1510
BCK 10
68
GNDD 11
10
SRIN
GNDD
V+3D
C1505
VDD
PMCKO
SO
VCOM3
IREF
VCOM2
VCOM1
GNDA1
SI
IOUTR+
SCK
IOUTR-
XCS
MUTE/DSD_R
C1303
B4B-PH-K-S
GNDD
SYSPOW 1
AC 2
STAND BY
*
STAND BY
*
R1904
F1901
*
R1905
GNDD
VNF1084-T
KN1901 KN1902 KN1903 KN1905 KN1904
*
R1901
*
R1902
*
C1901
GNDD
*
C1902
*
C1903
XRST
VCC3
ZEROL
GNDA2
ZEROR
IOUTL-
LRCK/GND
IOUTL+
DATA2/DSD_LS
BCK/GND
VCOM3
GNDD
VDD
PMCKO
SO
SI
VCC2
VCC1
PMCK/BCK
IREF
VCOM2
VCOM1
GNDA1
IOUTR+
SCK
IOUTR-
XCS
MUTE/DSD_RS
28
27
26
25
24
23
22
21
20
19
18
17
16
15
R1303
C1308
47/16
VCH1249
C1309
*
R1305
*
GNDD GNDD
2
3
47/16
VCH1249
16k(D)
PD-D6-J
1
C1406 CTF1661
*
F1402
C1307
C 1/2
26
HAZA
R1655
1
2
3
4
5
6
7
8
9
10
11
12
13
14
470p CH
R1304
*
GNDA
YF
XDACDT
XDACCK
XDACCS1
GNDD
GNDS
1
R1302
47
*
R1906
0.1
F
R1301
22
PMCK/BCK
R1903
GNDU 4
(AD)
C1310
C1512
LRCK/GND_1
DATA/DSD_L_1
PBCK/GND_1
GNDD
0.1
XDACRST
CN1503
3
Q1652
2SA1576A(QR)
7
4
C1306 CTF1661
*
14
7
C1302
6.8k
CTF1661
C1301
470/6.3
XDACRST
R1662
E
F1301 GNDA
E
C
Q1651(2/2)
UMH9N-T C2
B
R1653 GNDD
B2
4.7k
Q1651(1/2)
UMH9N-T C
R1656
E2
B
1k 2
14
4
GNDA
R1654
3
GNDA
1
V+5A
5
6
D1652
1k
E
7
DAN202U
IC1651 (2/4)
TC74VHC08FTS1
GNDA
IC1301
PCM1738EG-3
DAC Lch
C1653
1
2
3.3k
11
13
IC1651
(3/4)
V+3D
GNDD
TC74VHC08FTS1
IC1651(1/4)
SYSPOW 16
XDACRST 17
14
12
7
0.1
V+3D
VMUTE
*
R1406
*
IC1651 (4/4)
TC74VHC08FTS1
14
C1652
*
AC 15
R1661
47/16
VCH1249
16k(D)
C1408
47/16
VCH1249
8
0
(2125)
D1653
*
GNDU 14
R1403
10k
9
10
C1510
GNDU 13
C1407
C1409
TC74VHC08FTS1
VMUTE
R1651
V+58U 12
J11
GNDD
0.01
XSYSMUTE
*
GNDD 11
XSYSMUTE
DVDMUTE
V+12A
C1651
D
GNDD
V+58U
I
VCC1
MCLK/BCK
GNDD
C15110.1
V+56ST 10
GNDD
VCC2
BCK/GND
470p CH
R1405
XDFRST 8
XSYSMUTE 9
V+56ST 3
IOUTL+
DATA0/DSD_L
3.3k
(2125)
GND
IOUTL-
LRCK/GND
F1302
XDFCS 7
ZEROR
28
27
26
25
24
23
22
21
20
19
18
17
16
15
HAZA
XDFCLK 6
XDACDT
XDACCK
XDACCS2
GNDA2
R1652
R1516
22
R1517
22
14
VCC
13
12
11
10
9
8
VCC3
ZEROL
*
C1305 ACH7203
100/16 OS
GNDD 4
7 6 5
C1410
1
2
3
4
5
6
7
GNDD 3
CN2105
7 6 5
0.1
IC1502
TC74VHC125FTS1
SRIN 2
LRCK/GND_2
DATA/DSD_L_2
PBCK/GND_2
XRST
C1304
SROUT 1
IC1401
PCM1738EG-3
1
2
3
4
5
R1401
22
6
7
R1402
8
47
9
10
11
12
13
14
MCLK/BCK
CKS3382-
7 :DSD
0.01
CN1502
XDFDT 5
XDACRST
SROUT
6 :PCM (LEGATO : OFF)
*
C1405 ACH7203
100/16 OS
R1513
V+5A
5 :PCM (LEGATO : ON)
C1404
GNDD 16
PCM/DSD 17
C1403
XPCM
5
6
7
DAC Rch
XDACCS2
1 YF
XDACCS1
XDACCS2 15
5
6
7
0.1
XDACCK
XDACCS1 14
D
C1401
470/6.3
F1401
XDACCK 13
XDACDT
CTF1661
V+3D
R1511
10
R1512
10
C1402
B 2/2
GNDD 9
XDACDT 12
C
2
GNDD 7
*
CN953
DATA0 6
5
6
7
8
V+3D
RESISTOR
1608 SIZE
C1601
47/35
PMCK/BCK
*
R1610
10
R1612
56
TRANSISTOR
SOT-323 TYPE
SOT-346 TYPE
(UMD3,UMT3)
(SMD3,SMT3)
RS1/16S***J
2125 SIZE
PBCK/GND_1
RS1/10S***J
DISCRETE TYPE
GNDD
(AD)
SOT-363 TYPE
(UMT6)
CAPACITOR
1608 SIZE
CCSR***
CKSRYB***
DATA/DSD_L_1
LRCK/GND_1
DISCRETE TYPE
DIODE
SOD-323 TYPE
(UMD2)
2125 SIZE
CKSQ***
V+3D
C1605
C1704
0.1
C1705
9
14
100/16
C1116
0.1
C1115
C1118
0.1
470p
750
3
2 1
V-12A
GNDA
R1212
220
R1210 B
Q1201
1k
2SD2114K(VW) E
C
C1214
3 +
4
2 -
8
C1110
R1104
R1107
C1112
1.2k(D)
1.8k(D)
R1108
470p
CH
JA1201
PKB1042-
9
1
2
R
Rch OUT
1
2
L
Lch OUT
JA1101
PKB1041-
220
22k
R1109
470p
C1111
R1105
1.2k(D)
C1107
100/16
8
1200p
C1108
GNDA
E
GNDA
C1113
R1111
NP
47/50
VCH1255
750
1.2k(D)
6 -
8
5 +
4 IC1101 (2/2)
NJM5532MD
7
*
C1120
*
R1106
1.8k(D)
IC1102 (1/2)
NJM5532MD
1
V-12A
1500p CH
R1102
R1103
1.2k(D)
CH
330(D) PCN1041
C1105
C1109
*
(L)
1
R1115
GNDA
0.1
C1106
4 IC1101 (1/2)
NJM5532MD
*
C1119
3 +
GNDA
100/16
C1103
8
0.1
*
*
C1102
C1101
CH
2 -
8
CH
*
10
2SD2114K(VW) E
R1110
Q1101
B
1k
C
R1112
(L)
R1114
1500p
R1101
3 2 1
R1211
NP
4IC1102 (2/2)
NJM5532MD
100/16
5 +
R1209
C1210
C1208
0.1
R1205
1.8k(D)
1.2k(D)
*
C1220
7
330(D) PCN1041
C1104
1000p
D
V+12A
GNDA
VKS1002
GNDA
C1213
47/50
VCH1255
8
*
C1203
*
*
C1201
C1202
6 -
CH
4 IC1201 (2/2)
NJM5532MD
3
JA1702
C1717
V-12A
470p
CH
R1206
1.2k(D)
GNDA
5 +
(L)
(L)
(D)
(AD)
: AUDIO SIGNAL ROUTE(Lch)
: DIGITAL SIGNAL ROUTE
: AUDIO DATA SIGNAL ROUTE
F
C 1/2
27
PD-D6-J
5
C
GNDD
7
R1204
8
DIGITAL OUT
COAX & OPT
(D)
R1705
C1212
CH
100/16
V-12A
6 -
2
47
1.8k(D)
1.2k(D)
C1209
*
1.2k(D)
R1207
R1203
1500p CH
R1202
10
7
R1208
R1215
330(D) PCN1041
C1205
14
1
V+12A
GNDA
1
12 11
C1117
IC1201 (1/2)
4 NJM5532MD
14
C1211
3 +
L1701 R1706 L1702
1
5 75
1
4
2
3
3
4
PTL1017
F1702
VTL1172
CTF1661
IC1701
(5/6)
1200p
8
VKB1097-
C1708
IC1701(3/6)
7
100/16
0.1
2 -
*
C1219
*
C1207
C1206
CH
1500p
R1201
JA1701
GNDD
C1716
47/35
*
22
7 6
13
GNDS
0.01
R1704 C1710
7 4
0.01 YB
C1751
10
C1709
14
3
0
IC1701
(6/6)
330(D) PCN1041
C1204
GNDS
*1
(D)
8
IC1701(2/6)
R1703
2
7
V+12A
*1
C1722
7
5
R1214
C1721
SR-IN
F1701
DTF1068
C1711
0
14
R1751(0 )
R1752(0 )
V+3SPDIF
GNDD
IC1701(4/6)
IC1701(1/6)
TC74VHCU04FT
R1702 1 14
D1751
1SS355
C1721
C1722
1
3
2
1000p
(D)
330/6.3
0
VCH1248 (2125)
R1701
V+3D
GNDD
RKN1004-
GNDS
SROUT
SRIN
1 YF
C1707
56
SR-OUT
JA1752
XPCM
SPDIF
*1
C1753
*
*
C1714
R1622
C1713
*
1 YF
C1752
MCLK/BCK
PBCK/GND_2
LRCK/GND_2
DATA/DSD_L_2
1
3
2
*
*
R1619
R1213
22
R1616
56
RKN1004-
CEAT***
D1651
DAP202U
R1615
JA1751
YF
R1617
22
R1618 10
R1620
100
R1621
10
R1623
C1712
*
56
R1560
1
16
15
14
13
12
11
10
9
22k
R1614
*
VCC
ST
4A
4B
4Y
3A
3B
3Y
PCM/DSD SEL
Rch
R1613
SELECT
1A
1B
1Y
2A
2B
2Y
GND
B
DISCRETE TYPE
*
IC1602
TC74VHC157FTS1
1
2
3
4
5
6
7
8
DISCRETE TYPE
47/35
C1603
*
R1604
56
*
R1611
0.1
*
C 2/2
R1608
R1606 22
R1607 10
R1609
100
47/35
C1706
R1603
16
15
14
13
12
11
10
9
*
56
R1605
22
VCC
ST
4A
4B
4Y
3A
3B
3Y
*
C1114
R1602
*
SELECT
1A
1B
1Y
2A
2B
2Y
GND
PCM/DSD SEL
Lch
R1601
1
2
3
4
5
6
7
8
1 YF
C1602
A
IC1601
TC74VHC157FTS1
6
7
8
1
2
3
4
3.6 AJKB ASSY (2/2)
YF
CN2702
330 2W
1 .0
HAZ L
C1 8 1 3
1 0 0 0 /1 6
330 2W
C N 1851
CKS33801
-10.8V
+8.3V
GNDD
~
-
~
3
4
D3SBA20(B)
C1854
2
4700/25
D1852
1
GNDM
CAUTION : FOR CONTINUED PROTECTION
AGAINST RISK OF FIRE.
REPLACE ONLY WITH SAME TYPE
NO. 491003.HXR FOR IC1851
MFD, BY LITTELFUSE INC.
V+3D
*
C1833
1 YF
(2125)
DVDMUTE
(D)
SPDIF
470/16
RB501V-40
IC1831
BD7802FP
IN
OUT
1
3
2
C1832
C1831
D1831
CAUTION : FOR CONTINUED PROTECTION
AGAINST RISK OF FIRE.
REPLACE ONLY WITH SAME TYPE
NO. 491004.HXR FOR IC1852
MFD, BY LITTELFUSE INC.
+3.3V
R1838
*
C1836
R1836
10 0 / 1 6
1 YF
(2125)
C 18 3 8
C1834
4
GNDD
5
GNDD
6
V+6R5V
7
V+6R5V
8
GNDM
9
GNDM
10
GNDD
11
DVDMUTE
12
GNDD
13
D OU T
14
GNDD
15
GNDD
GN D D
100/16
R 18 4 2
3 3 0k
CAPACITOR
1608 SI ZE
C C S R ***
C K S R Y B ***
V+9D
V+58U
C1835
R 18 4 1 3 9 k ( F )
R 1 8 40
DISCRETE TYPE
R D 1/ 4MU F***J
R S 2LMF***J
V+9D
3
*
1k
IC1832
BA3948FP
1
5
2
3
4
33k(F)
R1835
2125 SI ZE
R S 1/ 10S ***J
R1837
120k(F)
RB501V-40
RESIST OR
1608 SI ZE
R S 1/ 16S ***J
V+12A
2
C 1/2
D1832
D
H
V+12A
AEK7018
(4A) >
C
D1 8 0 9
RB5 0 1 V-4 0
C1 8 0 9
0 .1
RB5 0 1 V-4 0
C1 8 1 5
*
*
C1 8 1 6
18
18
+
4
S1VB20/F03
+
1
~
J52
J
M ECHA2
IC1852
3
-
2
~
3
M ECHA1
R1804
B 680
V-12A
16
4 .7
0 .5 6 0 .5 6
ACE7 0 6 3 ACE7 0 6 3
R1 8 0 1
C1 8 0 2 C1 8 0 1
D I G ITAL2
2
C1 8 5 2
4
G
-17.2V
D1851
1
3 3 0 0 /2 5
D I G ITAL1
0( 2 1 2 5 )
R 1 8 1(12 1 2 5 )
0
IC1851 >
A E K 7 0 1 5(3 A )
330
E
R1 8 0 7
5
B
C
GN D A
C1 8 1 1
A UDIO2
2SA1514K(RS)
Q1805 R1805
+5V
Q 1 8 0 4S
C
E
2 S K 2 4 6 (Y ) - VCC
PNS1043
Q1806
2SB1186A
VAC4 11EQS10
R1810
Q1 8 0 2 3 3 0
2SC3906K(RS)
R1 8 0 6
6
E
C1 8 0 8
A UDIO1
D1804
B
R1802
680
B R1803
C
1 0 0 /2 5
7
D
Q1 8 0 3
2SD1763A
PNS1043
C
E
C1 8 0 7
A U DIO CT
D1803
11EQS10
S
C1 8 0 5 C1 8 0 6
S7B-EH
R 1 8 0 8 (2 1 2 5 )
0
R 1 8 0 9 (2 1 2 5 )
0
IC1802 *
C1 8 0 4
CN1801
G
1 0 0 /1 6 1 0 0 /1 6
IC1801 *
D
V+5A
IC1804
NJM78M05FA
IN
OUT PNC-4571
3
2
1 0 0 /2 5
11EQS10
4 7 0 0 /2 5 PCH1 1 5 6 4 7 0 0 /2 5 PCH1 1 5 6
C1 8 0 3
D1802
+VCC
V+12A
RB5 0 1 V-4 0
Q1801
2 S K 2 4 6 (Y )
D1801
VAC3 11EQS10
B
+10.8V
+17.2V
D1 8 0 6 D1 8 0 5
UDZ S1 2 (B) UDZ S1 2 (B)
D1 8 0 8
D1 8 0 7
AJKB ASSY
(AWM8075)
16
C 2/2
A
+5.8V
R1843
*
R1844
*
D1833
2125 SI ZE
C K S Q ***
RB501V-40
DISCRETE TYPE
T RANSIS TO R
S O T- 323 TY P E
S O T- 346 TY P E
(U MD 3, U MT3)
(S MD 3, S MT3)
4
*
1 YF
( 21 2 5 )
+11V
C 1 83 7
C E A T***
5
3 3 0k
1k
IC1833
1
2
3
C 18 3 9
R1839
E
+6.5V
BA00BC0WCP-V5
S O T- 363 TY P E
(U MT6)
(D)
: DIGITAL SIGNAL ROUTE
DISCRETE TYPE
DIODE
F
S O D - 323 TY P E
(UMD 2)
DISCRETE TYPE
C 2/2
C 2/2
28
PD-D6-J
1
2
3
4
5
6
7
8
A
B
C
D
E
F
29
PD-D6-J
5
6
7
8
1
2
3
4
J2601
S2B-PH-K-S
TROUT
14 TRGAIN
13
TRIN
12 VDET
11
SPDIF_RQ
10 GNDD
9
GNDD
8 MDATA
7
ACK
6 SCLK
5
SDATA
4 XDVDRST
3
XREADY
2 DVDPOWER
1
GNDD
15
NC
C2202
*
22k
R2114
R2103
NC
NC
MDATA
NC
NC
TRGAIN
TROUT
TRIN
R2151
220
ACK
0.1
C2113
XDACRST
R2175 0
R2112 47k
L2105
CTF1389
L2104
CTF1389
XDVRST
SCLK
L2103
CTF1389
L2102
CTF1389
KN2101
VNF1084
5
SDATA
MDATA
R2146
10k
R2147
10k
R2143 220
47k
TROUT
TRGAIN
TRIN
VDET
SPDIF_RQ
MDATA
ACK
SCLK
C2211
SDATA
*
XDVRST
XREADY
DVDP
CKS3829
LCDRS
NC
LCDRS
NC
XLCDRST
NC
NC
SDATA
UTEST
STEST
R2141 220
R2142 220
0.1
C2112
220
220
220
GNDD
DVD MODE
10/50
47k
R2154
*
XRST
C2219
LED2
2.2K
4
J2102
B4B-PH-K-S
R2153
MSDCT
3
GNDD
CN2503
1
2
V+5U
SHORT for
TEST POINT
D
LCD ASSY
(AWX8790)
Q2106
RT1N431M
V+5U
PF04PG-C12
E
Q2501
RT1N241M
JP2102
V+56ST
*
LED2
4
B
R2148
R2150
R2149
4 5
C2218
2
PF02PG-C07
SYSPOW
XSYSMUTE
C2111
SLR343BC4T
R2601
270
*
D2601
47/16 JQ
C2601
C2602
PLED ASSY
(AWX8795)
MSDCT
3
C
SCLK
RESET
0.01
D2104
2
1
CN2502
NC
XDVDRST
V+5B
3
2
PLED
DVDP
XDACRST
JP2101
C2114
*
C2501
V+5U
1
2
NC
VDD4
SYSPOW
VSS4
NC
4
220
*
Product TEST MODE
*
V+5U
VSS3
NC
VDD2
4
C2502
1
NC
NC
VSS2
S2501
VSA1005
5
6
1
VKN2024
[POWER-ON]
E
VDD3
SPDIF_RQ
SYSPOW2
NC
R2136
R2137
R2138
2
CN2106
R2111 220
C2103
C2101
1000p
0.1
R2110 220
MS_DCT
DIMMER
FLASHE/D
NC
NC
XDFCLK
LCDDAT
LCDCS
LCDCLK
XDFRST
XREADY
NC
MNSW ASSY
(AWX8794)
CN2501
E
SPDIF_RQ
LED3
BLOFF
DIMMER
MSDCT
R2165 220
R2162 220
R2163 220
R2116 220
NC
LED3
BLOFF
FLASHDO
FLASHCLK
NC
47k
47k
47k
*
NC
50
49
48
47
46
45
44
43
42
41
40
39
38
37
36
35
34
33
32
31
RT1N241M
Q2104
J13
NC
NC
NC
NC
XDFDT
XDFCS
GNDD
I
NC
µ-COM
LED1
F
NC
DVDACK
NC
VDET
KEY1
NC
3 3
1
XLCDRST
AC
SYSPOW
XDACRST
SIMUKE
NC
XSYSMUTE
LCDCK
XDFRST
XREADY
220
220
220
220
220
220
220
220
TRIN
NC
NC
LCDRS
R2128
R2129
R2127
R2130
R2131
R2132
R2133
R2134
TROUT
IC2101
PDC148A
220
XDFDT
XDFCS
XDFCLK
LCDDT
LCDCS
1
2
C2110
0.01
2 1
270
D2102
SLR-343VC(NPQ)
FLASHCLK
FLASHDO
FLASHE/D
1
0.1
1M
R2122 220
R2123 220
TRGAIN
NC
NC
R2160
R2126
1M
XDACRST
NC
XT2
VSS1
CF1
CF2
VDD1
NC
47k
VDET
LED3
R2135
C22160.1
C2109 0.01
REMOCON
XRESET
XT1
NC
R2125
V+5U
[PURE AUDIO]
X2101
ASS703410MHz
R2101
D2101
[STBY]
Q2101
RT1N241M
1k
SLI-343URCW(RST)
C
R2121
*
V+5U
D
C2115
C2105
KEY1
R2106 220
R2107 220
R2108 220
L2101
22u
220
XRST
R2176
R2115
DVDON/OFF
NC
NC
R2171
R2117
V+SW5U
R2113
1k
Q2102
RT1N241M
NC
ACPULSE
LED2
LED1
GNDD
R2403
22K
GNDD
6
*
470
CN13
T11
T51
S11
H13~H14
FU1
IROUT
47/35
W138
PRIMARY ASSY
TRANS ASSY
R2401
C2402
F
RT1P241M
W137
0.1
1
VCC
2
GND
3
C2401 R2402
VOUT
W136
D2402
1SS355
Q2401
2401
GP1UM28XK0VF
Q2402
RT1N431M
D E F
30
GNDD
FU2
PD-D6-J
KU
WY
AWX8799
AWX8800
AWX8802
120
220~230
B2P3-VH
ATT7079
ATT7078
PTT1368
PTT1369
REK1134
REK1058
(1.25A/250V) (500mA/250V)
-
PD-D6-S
RLFWP
AWX8801
AWX8797
110/220~240
B3P5-VH
ATT7080
PTT1370
AKX1033
AKR7001
REK1023
(1.25A/250V)
REK1134
(500mA/250V)
PD-D6-J
1
2
CN2703
Q2103
2SA1577(QR)
80 79 78 77 76 75 74 73 72 71 70 69 68 67 66 65 64 63 62 61 60 59 58 57 56 55 54 53 52 51
AC
LED2
LED1
SRIN
NC
NC
NC
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30
52492-0720
47K
V+5U
6
CN2101
0.1
C2217
C2220
ACH1246 R2155
0.047F
100
7
NC
H
V+5U
81
82
83
84
85
86
87
88
89
90
91
92
93
94
95
96
97
98
99
100
5
6
GNDD
220
R2140
3
4
VCC
VSS
D2105
1SS355
220
R2161
100k
R2104
2
V+5B
R2105 10k
C2102
*
+5.0V
FLASHE/D
FLASHDO
FLASHCLK
R2118
XRST
220
1
WEN/DI
WD0
WCLK
RST
C2226
B
2SC4097(PQR)
Q2108
D2103
1SS355
V+56ST
+5.2V
B
XDFDT
XDFCLK
XDFCS
XDFRST
XSYSMUTE
+5.6V
C
E
V+5U
CN2105
4
3
V+5U
+5.8V
NC
IROUT
2
1
IROUT
SRIN
GNDD
V+58U
NC
CN1502
SRIN
GNDD
GNDD
5
XDFCLK
6 XDFDT
7
XDFCS
8 XDFRST
9
XSYSMUTE
10 V+56ST
11
GNDD
12 V+58U
13
GNDD
14 GNDD
15
AC
16 SYSPOW
XDACRST
17
C 1/2
A
9607S-17F
3.7 LCD, PLED, MNSW, KEY, CONNECTOR, PRIMARY and TRANS ASSYS
3
4
5
6
• NOTE FOR FUSE REPLACEMENT
7
8
CAUTION - FOR CONTINUED PROTECTION AGAINST RISK OF FIRE.
REPLACE WITH SAME TYPE AND RATINGS OF FUSE.
3
Switches
S2301 : OPEN/CLOSE
S2302 : PLAY/STOP
RESISTOR
1608 SIZE
CN901
2
V+6R5V
V+9D
V+12A
GNDD
GNDD
CKS3380
V+12A
14 V+9D
V+9D
13
12 GNDD
GNDD
11
10 V+6R5V
V+6R5V
9
8 GNDM
GNDM
7
6 GNDD
DVDMUTE
5
4 GNDD
DOUT
3
2 GNDD
GNDD
1
CN2704
CEAT***
CN1851
TRANSISTOR
SOT-323 TYPE
SOT-346 TYPE
(UMD3,UMT3)
(SMD3,SMT3)
SOT-363 TYPE
(UMT6)
C 2/2
0.1
*
*
*
C2701C2705C2702C2703
*
C2704
(D)
C
CN2702
15
GNDM
RS1/10S***J
CAPACITOR
1608 SIZE
CKSRYB***
2125 SIZE
CKSQ***
*
GNDS
RS1/16S***J
TYPE
RD1/4MUF***J
R2701
*
R2702
1
3
4
6
5
7
8
10
9
11
12
13
14
15
16
17
18
20
19
22
21
24
23
KN2701
VNF1084
(NC)
25
26
27
28
29
VKN1205-
CN2701
CVBS
TROUT
TRIN
TRGAIN
SPDIF_RQ
TRKUP
DVDMUTE
VDET
GNDD
GNDD
ACK
MDATA
SDATA
SCLK
XREADY
XDVDRST
DVDPOWER
GNDD
GNDD
DOUT
GNDD
GNDD
GNDM
GNDM
V+6R5V
V+6R5V
V+9D
V+9D
V+12A
2125 SIZE
TYPE
DIODE
SOD-323 TYPE
(UMD2)
D
TYPE
2
2
1
1
NEUTRAL
1
W124
W129
PD-D6-J ONLY
0V
I
>
+12.8V
*
R12
22(1/4W MUF)
R13
NJM78M56FA
IN
OUT
1
3
IC11 2
>
C16
3
R14
3.3K
UDZS5R1(B)
GNDU
+5.6V
LA
LA
AUDIO1
5
AUDIO2
4
DIGITAL1
3
DIGITAL2
2
MECHA1
1
MECHA2
1
SYSPOW
2
AC
3
V+56ST
4
GNDU
J11
PF04PG-C07
PRIMARY ASSY
(PD-D6-J/KUXJ:AWX8800)(PD-D6-J/MYXJ5:AWX8799)
(PD-D6-S/RLFPWXJ:AWX8801)
PKP1017
TRANS ASSY
(PD-D6-J:AWX8802)
(PD-D6-S:AWX8797)
J
(D)
: DIGITAL SIGNAL ROUTE
6
F
D G H I J
31
PD-D6-J
5
E
J52
R51
RD1/4MUF4R7J
+12.4V
D14
1SS355
220/16
R15
10K
6
4
C15
8
*
T11
1
2
S1VB20/F03
D11 2
~
4
+
1
> ~
1000/25
PD-06-S
ONLY
W118
W120
Q11
RT1N241M
D15
S11
AKX1033
PD-06-J
ONLY
C14
L
1 2 3
>
W130
W131
T51
D13
1SS355 1SS355
4 5 6
17
>
D12
H13 FU2 H14
AKR7001 AKR7001
>
H
MECHA
15
16
6
7
PKP1018
R52
RD1/4MUF4R7J
14
5
J51-3
B2P3-VH
PD-D6-J
ONLY
*
C13
2
J13-2
PKP1015
4
2
J51-2
3
CN13
> RY11
ASR7013
3
AUDIOCT
6
CN1801
VH
110V
1
7
C 2/2
3
0.015
0.015
ACE7060 ACE7060
>
VL
2
C52
2
J12-2
PKP1014
J13 -1
>
220-240V
J51 -1
C51
3
4
XTF3004
N
VEF1040
*2(12,13)
CN1503
*
AKR7001
1
8
9 AUDIO
10
11
12
DIGITAL
13
1
PD-D6-S
ONLY
B3P5-VH
C 1/2
>
1 L11 2
0.01/275
ACE7013
STBY JP*4
>
FU1 H12
C11
L
H11
C12
J12 -1
>
C53
0.82
ACIN
C54
0.82
GNDD
2
VKN1191-
1
CN2703
F
CN2106
B
GNDD
B2P-SHF-1AA
CN2501
D
1
TROUT
TRGAIN 2
3
TRIN
VDET 4
5
SPDIF_RQ
GNDD 6
7
GNDD
MDATA 8
9
ACK
SCLK 10
11
SDATA
XDVDRST 12
13
XREADY
DVDPOWER 14
15
GNDD
10k
NOTES
CONNECTOR ASSY (AWX8796)
B 2/2
R2302
PLAY/STOP
OPEN/CLOSE
BLOFF
DIMMER
KEY1
H
VEF1040
2301
VSG1024
J2104
CABLE HOLDER
51048-0300
0
62
62
62
R2213
0
R2212
E2
E
2
GNDU
3
V+5U
1
VE+5
2
3
R2214
1SS355
D2209
DAN217
Q2204
UMH1N-T C2
B2
KEY1
1
E
2SC4081(QR)
D2210
CH
CH
CH
C2203
0.1
D2202
***
C2204
22p
D2203
***
C2205
22p
D2204
***
C2206
22P
D2205
***
C2207
22p
D2201
***
B
E
R2211
3
Q2204
UMH1N-T C
B
C Q2203
0
B
E
XLCDRST
CH
CQ2202
R2215
1K
R2210
C2201
2.2 YF
C2209
1000p R2219
1.8k
C2210
100/10
B
GNDD
1 2
LCDDT
LCDCK
LCDCS
LCDRS
CQ2201
D2208
GNDS
D2207
CTF1661
D2206
J2105
*
3
10k
V+5U
NSPW510BS-2224
S2302
8
R2301
7
VSG1024
6
*
5
R2216
3
S2301
XRESET
2
F2201
A
KEY ASSY
(AWX8792)
C2301
RS
1
G
J2104A
CSB
51048-0800
CABLE HOLDER
(FOR LCD INSERTION)
VSS
VDD
VO
WITH COG DRIVER
D20PYY0320E
SCL
4
AAV7111
LCD
CABLE HOLDER
51048-0300
SI
V2201
7
8
1
2
3
4
3.8 WAVEFORMS
Note : The encircled numbers denote measuring point in the schematic diagram.
A
B
DVDM ASSY
Measurement condition ;
No. 1 to 10 : reference A1 (DVD), T2-chp 19, Color-bar
No. 11 to 14 : reference A1 (DVD), T1
1
IC201-pin47 [FG]
V: 1V/div. H: 2msec/div.
GND
B
2
IC201-pin 39 [TROPENPWM]
V: 1V/div. H: 5µsec/div.
[Tray stops]
[Tray is opening]
[Tray is closing]
GND
GND
GND
C
3
IC201-pin37 [DMSO]
V: 1V/div. H: 10µsec/div.
V: 1V/div. H: 10µsec/div.
[TRAY OPEN]
V: 1V/div. H: 2sec/div.
[DVD PLAY]
[DMSO]
GND
GND
PLAY
D
GND
Tray :
opening
Pless OPEN key
Pless PLAY key
Braking a turn of disc
4
CN102-pin 2, 3, 4 (IC101-pin 30, 33, 35)
[SPINDLE (WVU)]
V: 2V/div. H: 2msec/div.
5
IC201-pin225 [ASPDIF AUDIO DIGITAL SIGNAL]
V: 2V/div. H: 500nsec/div.
GND
GND
E
F
32
PD-D6-J
1
2
3
4
5
C
6
7
8
AJKB ASSY
Measurement condition ;
No.1, No.3-No.6, No.8-No.10 : 1kHz, 0 dB(L/R), PCM
No.2, No.7-No.9
: 1kHz, 0 dB(L/R), DSD
1
Ch1: CN1501-pin 4 Ch3: CN1501-pin 6
[LRCK]
[DATA0]
Ch2: CN1501-pin 10 Ch4: CN1501-pin 2
[BCK]
[MCLK]
5
V: 1V/div.
H: 2us/div.
A
Ch1: IC1401-pin 4 Ch3: IC1401-pin 6
[LRCK]
[BCK]
Ch2: IC1401-pin 5 Ch4: IC1401-pin 7
[DATA]
[MCLK]
[PCM]
LEGATO: ON
V: 1V/div.
H: 2us/div.
9
JA1101 [Lch Out]
V: 10V/div.
H: 500us/div.
GND
Ch1
GND
Ch2
GND
Ch3
GND
Ch2
GND
GND Ch3
Ch4
2
Ch1
GND
Ch1: CN1501-pin 10 Ch3: CN1501-pin 8
[BCK]
[DATA1]
V: 1V/div.
Ch2: CN1501-pin 6
H: 500ns/div.
[DATA0]
Ch1
6
Ch1: IC1401-pin 4 Ch3: IC1401-pin 6
[PCM]
[LRCK]
LEGATO: OFF
[BCK]
Ch2: IC1401-pin 5 Ch4: IC1401-pin 7
V: 1V/div.
[MCLK]
[DATA]
H: 500ns/div.
GND
Ch2
GND
Ch3
GND
GND
Ch1: IC1501-pin 22 Ch3: IC1501-pin 24
[LRCK]
[DATA]
V: 1V/div.
Ch2: IC1501-pin 21
H: 500ns/div.
[BCK]
[LEGATO:ON]
Ch1
Ch2
Ch1: L1701-pin 1
[COAXIAL Out]
Ch2: JA1702-pin 3
[OPTICAL Out]
V: Ch 1 0.5V/div.
Ch 2 1V/div.
H: 200ns/div.
Ch1
GND
Ch2
GND
C
7
GND
Ch1: IC1401-pin 4
[GND]
Ch2: IC1401-pin 5
[DSD_L]
Ch3: IC1401-pin 6
[GND]
Ch4: IC1401-pin 7
[BCK]
[DSD]
V: 1V/div.
H: 500ns/div.
GND Ch1
GND
Ch2
GND
Ch3
GND
GND
Ch3
D
GND
Ch4
4
10
GND
Ch4
3
B
GND
GND Ch1
Ch2
Ch3
GND
Ch4
Ch1: IC1501-pin 22 Ch3: IC1501-pin 24
[LRCK]
[DATA]
Ch2: IC1501-pin 21
[LEGATO:OFF]
[BCK]
Ch1
V: 1V/div.
H: 2us/div.
GND
8
GND
Ch1: IC1101-pin 1
[LOUT1]
Ch3: IC1101-pin 7
[LOUT2]
Ch1
GND
Ch2
Ch2
GND
GND
Ch3
V: 1V/div.
H: 500us/div.
GND
E
F
33
PD-D6-J
5
6
7
8
1
D
2
3
4
LCD ASSY
SYSTEM Microcomputer(IC)<–>Each part communication waveform
A
1
Ch1: IC2101-pin 25
[XDFCLK]
Ch2: IC2101-pin 23
V: 2V/div.
[XDFDT]
H: 20us/div.
2
Ch1: IC2101-pin 25
[XDFCLK]
[MD]
Ch1
Ch2: IC2101-pin 24
[XDFCS]
V: 2V/div.
H: 20us/div.
6
[MD]
Ch1: 2401-pin 1
[2401Out]
(IR Receiver Out)
Ch2: IC2101-pin 7
[SR IN]
V: 1V/div.
H: 10ns/div.
Ch1
Ch1
GND
GND
GND
Ch2
GND
Ch2
Ch2
GND
GND
B
3
Ch1: IC2101-pin 28
Ch2: IC2101-pin 26
V: 2V/div.
[LCDCLK]
[LCDDATA]
H: 5us/div.
[ANY FUNCTION]
Ch1
GND
Ch2
GND
C
4
Ch1: IC2101-pin 51
[SCLK]
Ch1
Ch2: IC2101-pin 49
[SDATA]
V: 2V/div.
H: 10us/div.
[DVD]
GND
5
Ch1: IC2101-pin 51
[SCLK]
Ch2: IC2101-pin 50
[MDATA]
V: 2V/div.
H: 10us/div.
[DVD]
Ch1
GND
Ch2
Ch2
GND
GND
D
E
F
34
PD-D6-J
1
2
3
4
5
6
7
8
4. PCB CONNECTION DIAGRAM
NOTE FOR PCB DIAGRAMS :
1. Part numbers in PCB diagrams match those in the schematic
diagrams.
2. A comparison between the main parts of PCB and schematic
diagrams is shown below.
Symbol In PCB
Diagrams
Symbol In Schematic
Diagrams
B C E B C E
Part Name
A
3. The parts mounted on this PCB include all necessary parts for
several destinations.
For further information for respective destinations, be sure to
check with the schematic diagram.
4. View point of PCB diagrams.
Connector
Capacitor
Transistor
B C E
B
C
E B
C
SIDE A
E
Transistor
with resistor
B C E
D
G S D
B
G S
Field effect
transistor
D G S
P.C.Board
SIDE B
Chip Part
Resistor array
3-terminal
regulator
C
D
4.1 LOAB ASSY
SIDE A
SIDE B
A LOAB ASSY
A LOAB ASSY
VNP1836-C
LOAB
5
VWG
1
C102
C101
5
(VNP1836-C)
(VNP1836-C)
LOAD+
LOAD-
SW2
1
CN601
5
V+3D
(V+5D)
5
VWG2279VWG2346-
GND
1
CN602
1 2
E
PNE-1B1
S101
5
CN602
1
CN601
CN602
CN601
CN601
CN602
B CN104
M
LOADING MOTOR
ASSY
F
A
A
35
PD-D6-J
5
6
7
8
1
2
3
4
PD-D6-J
36
B
B
F
A CN601
CN104
R
CN104
A
R921
GNDD
C425
C426
C474
C475
C476
UP SIDE
C513 C514
R511 R512
L
5
R602
R601
C237
5
R209
1
R253
R251
C259
C262
C265
C454
R503
R243
R244
R245
R246
R252
C258
C263
C267
1
3
R269
C216
R206
B
C220
R232
C219 R284
R216
2/2
D
D861
D862
D821
D851
D852
R821
Q821
Q851
R225
4
129
1
CN204
R219
R218
R242
C290
1
5
IC204
R224
C223
C222
C201
C739
1.8V
C204
C213
R214
C215
1
IC711
R735
R740
D731
8
4
R713
R737
C801
R801
5
C738
R739
C
D801
LD_CD
R734
C143
C144
Q881 C
D881 C752
1
2
5
3
R750
L751
C735
C736
R732
R733
D733
BOTTOM SIDE
4
C151
E
22
GNDM
C103
C734
C733
L731
R764 C763
R763 C762
E
C754
5V
6.5V
1
C714
64
A
R207
C310
C206
3.3V
3.3V
L309
L308
C133
C142
C141
R940
C152
1
7
5
R919
4
3
R373
4
B
R931
R932
R933
R934
R935
R936
R937
R938
R939
LF
R313
R318
Q305 R315
C373
C732
C731
GNDD
C702
5
1
Q304
C371
R904
CN101
1
4
R906
R314
C374
R915
R914
R913
R912
R911
R910
R918
R907
R905
R903
C104
C140
1
8
1
R591
1
R504
R505
D C712
3.3V
Q307
1
17
CN953
IC201
R261 R260
R259 R258
R223 R235
R234
R270
R241
C252
R220
R221
C224
C270
C271
C272
C273
5
4
IC591
C502
C508
C503
9
R506
IC501
R265 R263
R264 R262
R280
R404
R405
5V
GNDD
C451
Q505
GNDA
R
CN905 1
R522
R521
C509
R595
R509
R508
R507
C1001
27
Q501
R513
R515
R516
Q502
R514
C504
R592
CN902
5V
Q481
R922
R923
R924 C421
C422
C423
C424
1
GNDD
C404
R518
R519
Q401
R401
R256 C268
C269
C507 R501 C501
X201
C251
C202
C506
C505 R502
R594
R310
C320
C309
R136
R135
R133
C102
IC101
C153
R151
R153
C101
120
130
(ANP7583-A)
R322
LD_DVD
C161
C145
R152
R154
24
CN102
CN901
1
12
1
C1002
C701
8V
29
R701
12V
CN103
GNDD
110
R325
R326
Q308
R321
R134
R132
R131
Q801
R762
IC761
R901
C511
C512
R416
R415
R414
R412
R411
192
193
256
C343
C346
C345
C344
C347
R714
C761
C131
C132
C146
C203
R712
1
3
R736
R761
R751
C751
D751
Q702
100
V
CN904
4
1
R436
R435
R434
R432
R431
R433
R413
R226
128
65
C221
C711
5
4
IC731
IC751 C753
R731
R702
Q701
90
Q504
Q503
80
Q506
R520
70
R237
R200
C713
R711
R738
C737
C740
Q731
L732
R881 R851 R822
R883 R853 R824
R882 R852 R823
100
R481
60
C242
R279
C243
C244
C209
R217
50
R201
R202
R204
R205
40
R211 C217
R210
30
C208
C210
C211
C212
R215
R213
R212
20
R227
10
10
R229
R228
0
X
Y 0
E
20
30
40
50
D
60
70
80
90
C
110
120
130
140
B
BOTTOM SIDE
UP SIDE
BOTTOM SIDE
UP SIDE
150
CN901
CN102
CN101
CN101
To STEPPING
To SPINDLE
Motor
Motor
To Pickup Assy
H CN2701
B DVDM ASSY
A
SIDE A
SIDE A
4.2 DVDM ASSY
1
2
3
4
5
6
7
8
PD-D6-J
37
B
B
F
130
120
(ANP7583-A)
110
100
90
80
70
60
50
40
30
20
10
0
X
0 Y
R1001
C401
E
10
IC401
C402
28
1
C412
C281
R247
C248
C236
C414
C415
C416
C246
C245
IC202
R422
R423
R424
C413
C405
R425
C453
1
R475
R908
R909
4 5
3 1
IC203
C214
R233
R248
IC205
C255
C298 L201
R254
C254
C241
R271
C299
X202
8 C455
C227
C228
C230
R230
R231
C250
C282
15 R426
C452
14
R474
C464
C465
C466
R273
R476
9
C253
16
C235
R268
C240
R257 R272
R266
R249
C249
R250
R255
R403
R402
C406
R421
28
R267
C233 C234
27
C239
R238
C247
C283
C287 C288
C232
C226 C231
R236
R285
25
IC451
R590
C261
C256
1
C591
C592
C264
C207
C257
C260
C266
C218
13
C500
R282
R240
CN951
R604
R603
R517
24
R1002
R281
1
C286
R239
C225
C289
C296
48
D
1
C205
R1003
C403
C411
C284
C285
54
20
30
40
50
60
70
R208
R500
Q201
2
80
CN952
1
1
3
D732
DVDM ASSY
AWM8 000
111
222
333
444
555
666
777
888
999
Q732
6 4
90
C
100
PRODUCTION CODE
R765
FC
R141
1
0 1 2 3 4 5 6 7 8 9
A
B
C
Q102
1
R142
0
Q101
0
0 1 2 3
C121
ICT
110
120
C1003
R917
R372
L901
130
R374
R375
R371
R916
R902
LF
C372
R303
R302
R301
R920
140
R406
B
150
B
DVDM ASSY
A
SIDE B
SIDE B
5
6
7
8
D1803
3
C
VA
D1804
D1801
BOND
BOND
Q1804
C1806
Q1806
2SB1186A
7
C1804
CN1801
IC1801
GNDS
IC1851
IC1802
R1807
A
12
V+
(WHITE)
V12
A
(RED)
C1213
C1113
T
R1655
NP
R1704
L1701
JA1701
(ORANGE)
C1704
C1110
1
8
R1703
1
C1711
C1710
4
5
C1212
C1211
D1653
R1651
C1210
R1701
C1652
FC
D1851
C1801
C1836
5
5
C1835
C1831
D1831
IC1831
R1551
C1602
R1501
4
4
R1611
R1610
R1609
R1607
R1606
C1605
R1115
8
R1102
C1105
1
8
R1202
C1205
1
R1214
C1204
R1201
IC1651
13.DOUT
14.GNDD
CN1851
LF
1
KN1903
1.V+12A
2,3.V+9D
4,5.GNDD
6,7.V+6R5V
8,9.GNDM
10.GNDD
11.DVDMUTE
12.GNDD
C1304
R1215
GNDA R1114
C1104
R1101
C1404
R1612
V+5A
R1702
R1617
R1621
C1308
C1405
R
PC
15
AWM8075
AWM
IC1701
L1702
R1705
1
C1705
7
14
C1653
8
ICT
14
C1111
C1219
15
14
7
C1803
C1852
IC1201
C1206
C1407
IC1401
C1708
JA1702
C1651
Q1651
R1652
Q1652
R1213
R1110
R1902
R1210
D1651
C1208
R1208
R1207
R1206
R1203
R1205
C1209
R1204
C1116
NP
Q1201
28
1
8
C1115
C1220
IC1102
C1117
C1207
C1119
R1662
GNDA
C1118
NP
IC1101
15
14
C1402
V+3D
C1854
C1307
C1106
C1108
C1109
R1104
C1808
C1112
U
58
V+
4
R1407
C1107
R1108
R1107
R1106
R1105
R1103
C1811
C1120
C1807
R1307
C1813
R1806
1
IC1804
Q1803
2SD1763A
AJKB Ass'y
C1805
Q1801
V+3D
1/2
THIS PRODUCT CONTAINS LEAD IN SOLDER AND CERTAIN
ELECTRICAL PARTS CONTAIN CHEMICALS WHICH ARE KNOWN TO THE STATE OF
CALIFORNIA TO CAUSE CANCER,BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM.
HEALTH & SAFETY CODE
SECTION 25249.6 - PROPOSITION 65
WARNING
BOND
C1834
R1835
BOND
D1832
R1838
R1837
R1836
C1833
C1832
28
1
IC1301
JA1201
JA1101
R1801
JA1752
SR-IN
1
17
D1852
IC1833
C1505
IC1832
1
C1506
C1507
17
CN1501
C1502
R1552
R1553
C1305
R1623
R1622
C1503
C1508
1
12
R1504
R1505
R1503
C1601
24
IC1601
C1603
R1620
R1618
C1303
R1301
C1406
C1408
V+3D
C1504
13
R1605
R1603
R1602
R1601
R1613
R1302
F1301
R1661
R1402
C1401
C1902
CN1501
JA1751
SR-OUT
D1802
B CN953
KN1904
C1722
VAC4
1
C1501
R1619
16
C1302
4
3
C1802
7
V+58U
IC1502
R1608
9
9
PD-D6-J
38
C
(PNP1489-A)
C
14
16
R1604
190
H CN2702
CN1851
230
8
V+
3D
1
FR4 P
210
R1502
160
7.AUDIO CT
6.AUDIO1
5.AUDIO2
4.DIGITAL1
3.DIGITAL2
2.MECHA1
1.MECHA2
30
Q1101
150
IC1602
140
4.GNDU
3.V+56ST
2.AC
1.SYSPOW
17.XDACRST
16.SYSPOW
15.AC
14.GNDU
13.GNDU
12.V+58U
11.GNDD
10.V+56ST
9.XSYSMUTE
8.XDFRST
7.XDFCS
6.XDFCLK
5.XDFDT
4.GNDD
3.GNDD
2.SRIN
1.SROUT
R1517
R1516
8
130
2
1
KN1902
220
D
D
N
G
F
V+3D
200
1
120
V+6R5V
180
E
50
8
R1560
R1615
R1614
D
KN1905
110
V+9D
170
IC1501
100
2.MCLK(22M)
4.LRCK
6.DATA0
8.DATA1
10.BCK
12.XDACDT
13.XDACCK
14.XDACCS1
15.XDACCS2
17.PCM/DSD
GNDD:1,3,5,7,
9,11,16
90
C
60
CAUTION
80
REPLACE WITH SAME TYPE NO.491003 FOR
IC1851, TYPE NO.491004 FOR IC1852,
MFD. BY LITTELFUSE INC.
70
C1838
40
B
KN1901
20
J J52
CN1081
J J11
CN1503
120
110
100
90
80
70
60
50
40
30
20
CN1502
D J2105
10
X
CN1503
SIDE A
10
0
Y
SIDE A
AJKB ASSY
C
A
4
3
2
1
4.3 AJKB ASSY
CN1502
1
IC1852
C1306
R1616
C1310
C1301
C1403
R1401
C1410
F1401
15.GNDD
AWM 0
1
2
3
4
5
6
7
8
9
0
1
2
3
4
5
6
7
8
9
1
0
1
2
3
4
5
6
7
8
9
0
1
2
3
4
5
6
7
8
9
LF
V+9D
C1903
C1712
F1702
V+12A
C1716
R1901
C1203
R
R1209
C1103
R1111
R1109
FR4 P
V+12A
R1303
C1102
D1809
V+
5A
V+12A
A
12
V-
C1816
D1808
R1804
V+3D
C1809
D1807
+VCC
R1803
CN1851
7
D1805
ATTENTION
R1513
R1512
R1515
R1507
R1508
R1509
R1510
+VCC
V+3D
R1843
D1833
R1844
V+9D
4.DIGITAL1
3.DIGITAL2
2.MECHA1
1.MECHA2
7.AUDIO CT
6.AUDIO1
5.AUDIO2
13.XDACCK
14.XDACCS1
15.XDACCS2
17.PCM/DSD
GNDD:1,3,5,7,
9,11,16
2.MCLK(22M)
4.LRCK
6.DATA0
8.DATA1
10.BCK
12.XDACDT
EN CAS DE REMPLACEMENT DES
FUSIBLES IC1851 N'UTILISER
QUE LA REFERENCE 491003
DE CHEZ LITTELFUSE INC.
1
D1806
EN CAS DE REMPLACEMENT DES
FUSIBLES IC1852 N'UTILISER
QUE LA REFERENCE 491004
DE CHEZ LITTELFUSE INC.
ATTENTION
G
N
D
A
Q1802
R1802
R1805
C
C
-V
-VCC
D1751
R1841
R1839
R1810
R1811
C1752
17.XDACRST
16.SYSPOW
15.AC
14.GNDU
13.GNDU
12.V+58U
11.GNDD
10.V+56ST
9.XSYSMUTE
8.XDFRST
7.XDFCS
6.XDFCLK
5.XDFDT
4.GNDD
3.GNDD
2.SRIN
1.SROUT
R1840
R1809
R1808
C1512
4.GNDU
3.V+56ST
2.AC
1.SYSPOW
C1721
C1511
20
GNDM
GNDD
R1842
C1751
C1837
GNDD
GNDA
GNDS
30
GNDM
GNDD
R1654
R1656
C1706
C1114
GNDM
C1714
15
C1717
R1706
R1906
C1713
V-12A
C1202
R1653
V+12A
F1701
D1652
R1406
R1212
R1211
R1905
R1112
GNDA
Q1805
C1815
C1214
V+9D
F1901
R1903
C1753
C1839
GNDA
C1101
7
1
C1707
C1201
C1409
V-12A
C1309
R1304
C1709
1.V+12A
2,3.V+9D
4,5.GNDD
6,7.V+6R5V
8,9.GNDM
10.GNDD
11.DVDMUTE
12.GNDD
13.DOUT
14.GNDD
15.GNDD
GNDD
40
V+6R5V
R1403
R1405
CN1503
R1305
6
C1901
CN1081
50
R1904
(PNP1489-A)
60
R1511
70
17
80
GNDD
90
C1510
100
17
5
6
V+
6R
5V
C
110
1
120
V+58U
SIDE B
4
1
5
7
8
C AJKB ASSY
SIDE B
10
CN1502
0
Y
A
10
X
20
30
40
B
50
60
70
80
90
C
100
110
120
130
GNDA
D
140
150
160
170
180
E
190
200
210
220
F
230
C
PD-D6-J
8
39
C2220
AWX8787
W184 V+56ST
W185
4
W195
W194
AWX8788
AWX8789
AWX8790
4.GNDD
3.V+5U
2.LED2
1.MSDCT
GNDD
1
JP2101
JP2102
UPPER SIDE
W187
GNDD
W186
CN2105
F CN2503
1
W193 GNDD
X2101
GNDD
C CN1502
[[ G ]]
C7
V+5B
W181
W158
15
W192 GNDD
UPPER SIDE
5.SDATA
4.XDVDRST
3.XREADY
2.DVDROWER
1,8,9.GNDD
15.TROUT
W188
14.TRGAIN
13.TRIN
12.VDET
11.SPDIF_RQ
8.MDATA
7.ACK
6.SCLK
W191
W189
17
W190
J2102
CN2101
7
C2219
J2102
W162
W161 V+5U
W146
1
W177
W200
W180
V+5B
AWX
V+5U
7.NC
6.VSS
5.VCC
4.RST
3.WCLK
2.WD0
1.WEN/DI
1
M CN2703
F
V+56ST
W160
C2210
W169
W182 V+5B
W183 GNDD
W159 V+5U
J2105
W166
W133
V+5U
W175 GNDD
GNDD
8
W165 V+5U
V+5U
W163
CN2106
W168 GNDD
J2104
W178
W179 V+5U
W172
D2101
W150
V2201
PD-D6-J
40
LCD Ass'y
W145
W164
170
W152
R
1
130
W154 V+5U
1
1.KEY1
2.VE+5
3.GNDU
190
W167
W147
V+5U
180
W142
W143
17.XDACRST
16.SYSPOW
15.AC
14.GNDD
13.GNDD
12.V+58U
11.GNDD
10.V+56ST
9.XSYSMUTE
8.XDFRST
7.XDFCS
6.XDFDT
5.XDFCLK
4.GNDD
3.GNDD
160
W141
GNDD
E
W144
W140
110
W151
PNE-1B1
W155
90
GNDD
W173
70
D2206
D2207
D2208
4
3
2
2.SRIN
1.IROUT
1
GNDD
150
W156
W139
140
D2102
GNDD
V+5U
W148 V+5U
GNDD
W170
C2402
CN2106
(PNP1488-A)
200
W157
100
W174
C
W176
W153 GNDD
80
W149
KN2101
60
W171 GNDD
50
W138
40
CN2105
30
W136
B
2401
W137
20
R
120
D
PNE-1B1
10
220
210
200
190
180
170
Y
4
3
2
1
4.4 LCD ASSY
A
SIDE A
D LCD ASSY
X 0
D
D
5
6
7
8
SIDE B
SIDE B
A
D
LCD ASSY
220
210
200
190
180
170
Y
R
0 X
PNE-1B1
10
20
C2401
B
30
Q2402
Q2203
R2165
V+5U
80
D2202
C2203
D2201
C2207
D2203
C2204
GNDD
GNDD
R2161
C2206
R2149
1
D2205
V+5U
51
8
R2132
R2115
15.TROUT
14.TRGAIN
13.TRIN
12.VDET
R2147 L2103
L2104
R2146
GNDD
R2142
R2134
R2160
160
E
170
R2113
Q2102
GNDD
Q2108
V+5U
R2114
Q2103
R2103
GNDD
R2176
CN2106
180
V+5U
F2201
C2202
GNDD
C2211
C2226
17
1
150
C2205
C2209
15
130
140
11.SPDIF_RQ
8.MDATA
7.ACK
6.SCLK
5.SDATA
4.XDVRST
3.XREADY
2.DVDP
1,9,10.GNDD
50
LF
R2133
C2105
1.IROUT
2.SRIN
5.XDFCLK
6.XDFDT
7.XDFCS
8.XDFRST
9.XSYSMUTE
D2204
D
120
R2151
R2148
R2150
R2130
R2219
IC2101
C2201
80
30
R2140
L2102
R2175
CN2105
100
U5+V
C2102
R2116
V+5U
C2113
10.V+56ST
12.V+58U
15.AC
L2105 16.SYSPOW
R2112 17.XDCRST
3,4,11,
13,14.GNDD
V+5U
D2103
90
110
C2103
31
R2143
1
R2138
R2127
R2129
R2128
V+56ST
C2112
R2141
C2111
R2136
C
R2111
81
1
0
10
GNDD
R2121
C2216
C2115
R2108
D2105
GNDD
1.WEN/DI
2.WD0
3.WCLK
4.RST
5.VCC
6.VSS
7.NC
R2131
R2162
R2171
R2163
R2122
R2118
R2117
R2107
R2105
V+5B
PNE-1B1
R2155
GNDD
CN2101
R2104
C2101
V+5U
R2110
V+5B
70
Q2101
V+5U
L2101
60
GNDD
R2125
R
R2215
R2216
R2106
4
V+5B
V+56ST
1
J2102
R2213
R2214
R2153
D2104
C2114
GNDD
DDNG
C2217
R2137
Q2401 Q2104
GNDD
R2212
7
C2218
R2211
R2154
R2126
C2109
C2110
R2123
50
R2135
V+5U
Q2201
Q2106
1
D2210
Q2202
R2210
NP
GNDD
GNDD
1.MSDCT
2.LED2
3.V+5U
4.GNDD
40
D2402
R2101
R2403
Q2204
R2401
D2209
V+5U
GNDD
R2402
1
190
3 1.KEY1
2.VE+5
3.GNDU
(PNP1488-A)
200
F
D
D
41
PD-D6-J
5
6
7
8
1
2
3
4
4.5 PLED, KEY and PRIMARY ASSYS
SIDE A
SIDE A
A
E
G KEY ASSY
PLED ASSY
240
240
F CN2502
[[ G ]]
C7
AWX8795
230
D2601
210
1
1.V+5U
2.PLED
PLED
ASS'Y
PNE-1B1
R
220
B
J2601
C2602
J2601
(PNP1488-A)
230
KEY ASS'Y
2301
R
220
PNE-1B1
W317
AWX8792
W318
210
AWX
[[ G ]]
C7
0
X
Y
10
20
30
40
PC
200
50
OPEN/CLOSE
1.KEY1
2.VE+5
3.GNDU
S2301
S2302
J2104A
1
190
STOP/PLAY
180
C
(PNP1488-A)
170
J
PRIMARY ASSY
190
X
Y
200
210
220
230
240
180
170
R
WHITE
J51-3
YELLOW
J51-2
RED
J51 -1
[[ G ]]
C7
PNE-1B1
VL
NEUTRAL
160
D
VH
PRIMARY
T51
150
140
130
120
E
110
SECONDARY
TRANS ASS'Y
W316
100
W312
W313
AWX8797
C53
AWX8802
AWX
R52
7
7.AUDIOCT
6.AUDIO1
5.AUDIO2
4.DIGITAL1
3.DIGITAL2
2.MECHA1
1.MECHA2
90
Y
F
160
X
170
J52
C52
R51
1
PTT1367- (JJ)
PTT1368- (WY)
(PNP1488-A)
80
C51
C54
PTT1369- (KU)
PTT1370- (RLF)
C CN1802
J52
180
190
200
210
220
230
E G J
E G J
42
PD-D6-J
1
2
3
4
5
6
7
8
SIDE B
SIDE B
A
G KEY ASSY
E
PLED ASSY
240
240
PNE-1B1
230
J2601
PLED
V+5U
210
220
R2601
LF
230
C2601
R
220
LF
B
210
(PNP1488-A)
R
PNE-1B1
STOP/PLAY
200
220
30
20
10
0
X
Y
190
3
230
40
1
R2301 C2301
R2302
1.KEY1
2.VE+5
3.GNDU
180
(PNP1488-A)
240
50
OPEN/CLOSE
C
170
210
200
190
X
J
Y
PRIMARY ASSY
180
170
VH
VL
D
160
NEUTRAL
150
PRIMARY
140
R
PNE-1B1
130
120
E
110
SECONDARY
100
LF
7
(PNP1488-A)
230
220
210
7.AUDIOCT
6.AUDIO1
5.AUDIO2
4.DIGITAL1
3.DIGITAL2
2.MECHA1
1.MECHA2
1
90
J52
200
190
80
180
170
Y
160
F
X
E G J
E G J
43
PD-D6-J
5
6
7
8
1
2
3
4
4.6 CONNECTOR and MNSW ASSYS
SIDE A
SIDE A
A
H CONNECTOR ASSY
B CN901
10
GNDD
AWX8796
CONNECTOR ASS'Y
CN2704
D CN2106
CN2703
W110 V+12A
W103
KN2701
1.TROUT
TRGAIN
TRIN
VDET
SPDIF_RQ
GNDD
GNDD
MDATA
ACK
SCLK
SDATA
XDVDRST
XREADY
DVDPOWER
15.GNDD
15
DOUT
W102
12.GNDD
11.GNDD
W112 XREADY 10.DOUT
9.GNDD
8.GNDD
W113 SDATA
7.GNDM
W114 ACK
6.GNDM
5.V+6R5V
4.V+6R5V
CN2703
1 3.V+9D
2.V+9D
1.V+12A
SPDIF_RQ
W101
2
TRIN
W104
PNE-1B1
W111 DVDPOWER
1
W105
1
2.GNDD
1.CVBS
W108 V+9M
CN2701
29
CN2702
15.V+12A
14.V+9D
13.V+9D
12.GNDD
11.GNDD
10.V+6R5V
9.V+6R5V
8.GNDM
7.GNDM
6.GNDD
5.DVDMUTE
4.GNDD
3.DOUT
2.GNDD
1.GNDD
20
GNDD
[[ G ]]
C7
W109 V+9D
15
30
W132
R
W107 GNDM
40
21.GNDD
20.GNDD
19.ACK
18.MDATA
17.SDATA
16.SCLK
15.XREADY
14.XDVDRST
13.DVDPOWER
W106 GNDD
29.CVBS
28.TROUT
27.TRIN
26.TRGAIN
25.SPDIF
_RQ
24.TRKUP
23.DVD
MUTE
22.VDET
CN2701
1
B
CN2702
C CN1851
50
GNDD
(PNP1488-A)
0
Y
C
X
F
40
60
50
70
80
90
100
110
120
130
MNSW ASSY
D
50
W314
[[ G ]]
C7
W315
AWX 8794
AWX
40
C2501
CN2503
4
1.MSDCT
2.LED2
3.V+5U
4.GNDD
10
1
R
PNE-1B1
(PNP1488-A)
0
Y
130
140
150
160
170
180
190
200
210
D J2102
PRIMARY
MNSW ASS'Y
CN2503
2.PLED
1.V+5U
1 2
CN2502
20
E
E J2601
CN2501
30
CN2502
S2501
220
230
X
F
H F
H F
44
PD-D6-J
1
2
3
4
20
CN2702
30
1
10
0
40
50
60
70
80
90
X
100
Y
50
40
C2502
30
E
20
10
PNE-1B1
1.MSDCT
2.LED2
3.V+5U
4.GNDD
0
130 X
140
150
160
170
180
190
200
210
220
230
Y
8
7
R2702
1
2
15. GNDD
DVDPOWER
CN2703
15
SDATA
XREADY
15
ACK
MDATA
GNDD
GNDD
XREADY
XDVDRST
SDATA
DVDPOWER SCLK
C2705
ACK
110
120
2.PLED
1.V+5U
CN2503 CN2502
V+9M
V+9D
V+12A
1
TRIN
40
GNDD
9.GNDD
8.GNDD
7.GNDM
6.GNDM
5.V+6R5V
4.V+6R5V
3.V+9D
2.V+9D
1.V+12A
DOUT
SPDIF_RQ
VDET
TRIN
TRGAIN
1. TROUT
PRIMARY
(PNP1488-A)
GNDD
GNDD
C2702
C2701
29
1
15.V+12A
14.V+9D
13.V+9D
12.GNDD
11.GNDD
10.V+6R5V
9.V+6R5V
8.GNDM
7.GNDM
3.DOUT
6.GNDD
5.DVDMUTE
2.GNDD
1.GNDD
4.GNDD
SPDIF_RQ
LF
R2701
R
50
CN2701
B
C2703
PNE-1B1
27.TRIN
26.TRGAIN
29.CVBS
25.SPDIF
28.TROUT
_RQ
24.TRKUP
23.DVD
MUTE
22.VDET
21.GNDD
20.GNDD
19.ACK
18.MDATA
17.SDATA
16.SCLK
15.XREADY
GNDD
14.XDVDRST
13.DVDPOWER
12.GNDD
11.GNDD
GNDM
10.DOUT
C2704
C
130
R
1
4
6
5
MNSW ASSY
F
CONNECTOR ASSY
H
8
7
6
5
SIDE B
SIDE B
A
(PNP1488-A)
D
LF
Q2501
F
H F
H F
45
PD-D6-J
1
2
3
4
4.7 PRIMARY ASSY
SIDE A
SIDE A
A
I
PRIMARY ASSY
F CN2501
J13
180
12
170
PRIMARY ASS'Y
CN13
J13 -1
C12
120
WHITE
PRIMARY
RISK OF FIRE
REPLACE FUSE
AS MARKED.
C CN1503
W122
W128
L
N
13
FU1
NJM78M56FA
IC11
4.GNDU
3.V+5.6ST
2.AC
1.SYSPOW
W118
W120
W119
W115
W117
R13
R12
T11
W116
C15
HIGH
RY11
LOW
[[ G ]]
C7
C13
70
YELLOW
J12 -1
W123
D11
C16
W121 GNDU
J11 4
1
J11
100
D
W127
C11
J12-2
SECONDARY
110
80
W126
W125
W131
W130
R
PNE-1B1
C
90
ORANGE
L11
H12
W311
W134
H11
W310
130
8798
8799
8800
8801
except
RLF model
RED
FU2
W309
AWX
AWX
AWX
AWX
AWX
W135
H13
W308
140
W129
W307
W124
11
150
J13-2
RLF model
H14
3.VL
2.VH
1.NEUTRAL
3
160
1
B
60
S11
50
(PNP1488-A)
J12
40
Y
0
X
E
10
20
30
40
50
60
70
80
90
100
110
120
130
140
150
160
AC IN
F
I
I
46
PD-D6-J
1
2
3
4
5
6
7
8
SIDE B
SIDE B
A
I
PRIMARY ASSY
180
J13
170
VL
VH
NEUTRAL
1
3
160
B
150
140
LF
130
120
PRIMARY
SECONDARY
C
110
1
J11
4
C14
100
GNDU
4.GNDU
3.V+5.6ST
2.]AC
1.SYSPOW
90
R15
D14
R14
D15
80
Q11
D12
R
70
PNE-1B1
D
D13
60
50
(PNP1488-A)
J12
40
Y
160
150
140
130
120
110
100
90
80
70
60
50
40
30
20
10
0
X
E
F
I
I
47
PD-D6-J
5
6
7
8
1
2
3
4
5. PCB PARTS LIST
NOTES:
A
B
Parts marked by "NSP" are generally unavailable because they are not in our Master Spare Parts List.
The mark found on some component parts indicates the importance of the safety factor of the part.
Therefore, when replacing, be sure to use parts of identical designation.
When ordering resistors, first convert resistance values into code form as shown in the following examples.
Ex.1 When there are 2 effective digits (any digit apart from 0), such as 560 ohm and 47k ohm (tolerance is shown by J=5%,
and K=10%).
560 Ω
56 x 10 1
RD1/4PU 5 6 1 J
561
47k Ω
RD1/4PU 4 7 3 J
47 x 10 3
473
0.5 Ω
RN2H R 5 0 K
R50
1Ω
RS1P 1 R 0 K
1R0
Ex.2 When there are 3 effective digits (such as in high precision metal film resistors).
5.62k Ω
562 x 10 1
5621
RN1/4PC 5 6 2 1 F
Meaning of the figures and others in the parentheses in the parts list.
Example) IC 301 is on the point (face A, 91 of x-axis, and 111 of y-axis) of the corresponding
PC board.
IC 301 (A, 91, 111) IC NJM2068V
LIST OF WHOLE PCB ASSEMBLIES
PD-D6-J/
KUXJ/CA
PD-D6-J/
MYXJ5
PD-D6-S/
RLFPWXJ
1..LOADER ASSY
2..LOAB ASSY
VWT1230
VWG2346
VWT1230
VWG2346
VWT1230
VWG2346
1..DVDM ASSY
AWM8069
AWM8069
AWM8069
1..FLKB ASSY
2..LCD ASSY
2..KEY ASSY
2..MNSW ASSY
2..PLED ASSY
2..CONNECTOR ASSY
2..PRIMARY ASSY
2..TRANS ASSY
AWM8072
AWX8790
AWX8792
AWX8794
AWX8795
AWX8796
AWX8800
AWX8802
AWM8071
AWX8790
AWX8792
AWX8794
AWX8795
AWX8796
AWX8799
AWX8802
AWM8073
AWX8790
AWX8792
AWX8794
AWX8795
AWX8796
AWX8801
AWX8797
1..AJKB ASSY
AWM8075
AWM8075
AWM8075
Mark
NSP
NSP
C
D
I
Symbol and Description
PRIMARY ASSY
AWX8800, AWX8799 and AWX8801 are constructed the same except for the following :
Mark
>
>
>
>
J
E
Symbol and Description
T11
S11 VOLTAGE SELECTOR
CN13 2P-VH CONNECTOR
CN13 3P-VH CONNECTOR
H13, H14
AWX8800
AWX8799
ATT7079
ATT7078
AWX8801
ATT7080
Not used
B2P3-VH
Not used
Not used
Not used
B2P3-VH
Not used
Not used
AKX1033
Not used
B3P5-VH
AKR7001
TRANS ASSY
AWX8802 and AWX8797 are constructed the same except for the following :
Mark
>
>
Symbol and Description
J51 2P CONNECTOR ASSY
J51 3P CONNECTOR ASSY
AWX8802
AWX8797
PKP1018
Not used
Not used
PKP1016
7 PCB PARTS LIST
Mark No.
A
Description
Mark No.
Part No.
MISCELLANEOUS
MISCELLANEOUS
F
Part No.
B DVDM ASSY
LOAB ASSY
S 101
CN602 CONNECTOR
CN601 CONNECTOR
Description
IC
IC
IC
IC
IC
VSK1011
S2B-PH-K
S5B-PH-K
48
101
201
202
203
204
(A,62,106) 6CH DRIVER IC
(A,50,44) DVD IC
(B,34,25) IC
(B,34,54) FLASH ROM
(A,19,44) EEPROM
BD7995EFS
MT1389EE/B2-L
K4S641632K-UC75
AYW7119
S-24CS04AFJ
3
4
PD-D6-J
1
2
5
6
Mark No.
Description
Part No.
IC
>IC
>IC
>IC
Q
205
711
731
751
101
(B,54,46) IC
(A,33,74) REGULATOR (1.8V)
(A,29,92) DC/DC CONTROLLER IC
(A,32,113) REGULATOR IC (5.0V)
(B,55,113) TRANSISTOR
TC7SH08FUS1
MM1661JH
R1224N102H
MM1565AF
2SA1576A
Q
Q
Q
Q
Q
102
304
305
307
308
(B,60,116) DIGITAL TRANSISTOR
(A,77,127) TRANSISTOR
(A,84,125) NMOS FET TRANSISTOR
(A,71,87) CHIP TRANSISTOR
(A,63,87) CHIP TRANSISTOR
DTC124EUA
2SC4081
UM5K1N
HN1A01F
HN1A01F
Q
Q
Q
>Q
Q
506
701
702
732
801
(A,114,69) CHIP TRANSISTOR
(A,24,134) TRANSISTOR
(A,27,129) DIGITAL TRANSISTOR
(B,22,90) FET
(A,50,87) DIGITAL TRANSISTOR
DTC114YUA
2SA1576A
DTC124EUA
RSQ035P03
DTC124EUA
Q
Q
Q
D
D
821
851
881
731
732
(A,42,86)
(A,42,89)
(A,42,93)
(A,29,87)
(B,18,92)
TRANSISTOR
TRANSISTOR
TRANSISTOR
DIODE
DIODE
2SA1576A
2SA1576A
2SA1576A
1SS355
RSX201L-30
D
D
D
D
D
733
801
821
851
852
(A,24,94)
(A,50,85)
(A,46,86)
(A,46,89)
(A,42,82)
DIODE
DIODE
DIODE
DIODE
DIODE
1SS355
UDZS4R7(B)
1SS355
1SS355
1SS355
D
D
D
L
L
861
862
881
731
732
(A,46,82) DIODE
(A,46,83) DIODE
(A,46,93) DIODE
(A,23,109) POWER INDUCTOR(22U)
(A,22,84) POWER INDUCTOR
1SS355
1SS355
1SS355
DTL1099
ATH7011
L
L
L
L
L
751
901
931
936
937
(A,34,99) INDUCTOR
(B,44,129) INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
CTF1395
CTF1334
CTF1384
CTF1389
CTF1389
L 938
L 939
X 202
CN101
CN102
INDUCTOR
INDUCTOR
(B,76,48) CRYSTAL OSCILLATOR
(A,88,140) CONNECTOR
(A,69,142) 12P CONNECTOR
CTF1389
CTF1389
ASS7075
CKS5045
AKN7031
CN103
CN104
CN901
CN953
(A,103,139) 04P CONNECTOR
(A,79,9) CONNECTOR
(A,41,142) 29P CONNECTOR
(A,116,102) CONNECTOR
RKN1045
AKM1291
VKN1321
CKS3885
RESISTORS
R
R
R
R
R
131
132
133
134
135
(A,61,95)
(A,63,95)
(A,66,95)
(A,65,95)
(A,68,95)
RS1/10S4R7J
RS1/10S4R7J
RS1/10S4R7J
RS1/10S4R7J
RS1/10S4R7J
R
R
R
R
R
136
141
142
151
152
(A,70,95)
(B,54,110)
(B,58,114)
(A,59,117)
(A,59,121)
RS1/10S4R7J
RS1/16S124J
RS1/16S223J
RS1/10S1R0J
RS1/10S1R8J
R
R
R
R
153
154
200
201
(A,57,117)
(A,57,121)
(A,25,56)
(A,49,67)
RS1/10S1R0J
RS1/10S1R8J
RS1/10S0R0J
RS1/16S152J
7
Mark No.
8
Description
Part No.
R 202 (A,48,67)
RS1/16S223J
R
R
R
R
R
203
204
205
206
207
(A,47,67)
(A,45,67)
(A,46,64)
(A,65,60)
RS1/16S0R0J
RS1/16S223J
RS1/16S184J
RS1/16S224J
RS1/10S0R0J
R
R
R
R
R
208
209
212
213
214
(B,27,71)
(A,57,16)
(A,40,70)
(A,41,70)
(A,45,72)
RS1/10S0R0J
RS1/10S0R0J
RS1/16S103J
RS1/16S103J
RS1/16S0R0J
R
R
R
R
R
216
217
218
219
221
(A,36,62)
(A,31,61)
(A,18,37)
(A,18,35)
(A,25,44)
RS1/16S0R0J
RS1/10S0R0J
RS1/16S103J
RS1/16S103J
RS1/16S330J
R
R
R
R
R
223
224
225
226
227
(A,29,35)
(A,29,49)
(A,40,23) CHIP RESISTOR ARRAY
(A,43,23)
(A,44,23)
RS1/16S330J
RS1/16S330J
RAB4C330J
RS1/16S330J
RS1/16S330J
R
R
R
R
R
229
230
231
232
233
(A,48,24)
(B,71,35)
(B,71,37)
(A,34,60)
(B,42,50)
RS1/16S330J
RS1/16S101J
RS1/16S101J
RS1/16S0R0J
RS1/16S0R0J
R
R
R
R
R
234
235
237
238
241
(A,26,42)
(A,26,41)
(A,23,41)
(B,60,35)
(A,71,36)
RS1/16S330J
RS1/16S472J
RS1/16S330J
RS1/16S103J
RS1/16S330J
R
R
R
R
R
242
243
244
246
247
(A,71,37)
(A,69,39)
(A,69,41)
(A,69,43)
(B,58,37)
RS1/16S330J
RS1/16S100J
RS1/16S330J
RS1/16S330J
RS1/16S103J
R
R
R
R
R
248
249
250
254
255
(B,58,46)
(B,59,40)
(B,50,47)
(B,65,48)
(B,57,52)
RS1/16S330J
RS1/16S103J
RS1/16S0R0J
RS1/16S754J
RS1/16S104J
R
R
R
R
R
256
257
258
259
260
(A,73,59)
(B,64,42)
(A,23,39)
(A,26,39)
(A,24,37)
RS1/16S153J
RS1/16S0R0J
RS1/16S330J
RS1/16S330J
RS1/16S330J
R
R
R
R
R
261
266
267
268
269
(A,27,38)
(B,51,38)
(B,56,30)
(B,68,37)
(A,73,33)
RS1/16S330J
RS1/16S330J
RS1/16S0R0J
RS1/16S101J
RS1/16S102J
R
R
R
R
R
270
271
272
273
279
(A,73,35)
(B,73,48)
(B,69,42)
(B,81,46)
(A,63,25)
RS1/16S101J
RS1/16S101J
RS1/16S330J
RS1/16S0R0J
RS1/16S5600F
R
R
R
R
281
284
301
302
(B,19,33)
(A,34,61)
(B,89,136)
(B,86,136)
RS1/10S0R0J
RS1/16S103J
RS1/10S0R0J
RS1/10S0R0J
6
B
C
D
E
F
49
PD-D6-J
5
A
7
8
1
Mark No.
A
2
Description
3
Part No.
Mark No.
4
Description
Part No.
R 303 (B,87,133)
RS1/10S0R0J
R 933 (A,104,99)
RS1/16S0R0J
R
R
R
R
R
313
314
315
318
321
(A,80,125)
(A,75,125)
(A,80,128)
(A,80,126)
(A,61,87)
RS1/16S104J
RS1/16S103J
RS1/16S103J
RS1/16S104J
RS1/16S4R7J
R 934 (A,104,101)
R 935 (A,104,103)
R 940 (A,104,111)
RS1/16S0R0J
RS1/16S0R0J
RS1/16S0R0J
R
R
R
R
R
322
325
326
406
412
(A,73,87)
(A,68,87)
(A,66,87)
(B,77,142)
(A,70,23)
RS1/16S4R7J
RS1/16S4R7J
RS1/16S4R7J
RS1/16S750J
RS1/16S750J
C
C
C
C
C
101
102
103
104
121
(A,49,120)
(A,73,101)
(A,66,116)
(A,61,117)
(B,61,112)
CEVW101M16
CKSRYB105K10
CKSRYB105K10
CKSRYB105K10
CKSRYB105K10
R
R
R
R
R
517
520
590
591
592
(B,105,68)
(A,111,69)
(B,90,52)
(A,83,50)
(A,79,55)
RS1/16S102J
RS1/16S102J
RS1/10S0R0J
RS1/16S0R0J
RS1/16S100J
C
C
C
C
C
131
132
140
144
145
(A,52,103)
(A,49,108) CHIP PV CAPACITOR
(A,60,137)
(A,62,99)
(A,64,98)
CKSRYB104K25
VCH1252
CKSRYB105K10
CKSRYB222K50
CKSRYB222K50
R
R
R
R
R
595
701
702
732
733
(A,80,64)
(A,24,137)
(A,27,134)
(A,25,91)
(A,25,93)
RS1/16S0R0J
RS1/16S473J
RS1/16S103J
RS1/10S100J
RS1/16S220J
C
C
C
C
C
146
151
152
153
161
(A,60,98)
(A,68,114)
(A,71,114)
(A,73,111)
(A,58,96)
CKSRYB222K50
CKSRYB103K50
CKSRYB103K50
CKSRYB103K50
CKSRYB102K50
R
R
R
R
R
734
735
736
737
738
(A,30,89)
(A,29,84)
(A,32,93)
(A,31,83)
(A,29,82)
RS1/16S473J
RS1/16S272J
RS1/16S1802F
RS1/16S2702F
RS1/16S1502F
C
C
C
C
C
201
202
203
204
205
(A,21,52) CHIP ELECT.CAPACITOR
(A,69,64) CHIP ELECT.CAPACITOR
(A,55,78) CHIP ELECT.CAPACITOR
(A,52,63)
(B,52,69)
CEVW221M4
CEVW221M4
CEVW470M16
CKSRYB104K25
CKSRYB104K25
R
R
R
R
R
739
740
750
751
765
(A,19,78)
(A,29,85)
(A,30,99)
(A,33,119)
(B,39,108)
RS1/16S0R0J
RS1/16S0R0J
RS1/16S0R0J
RS1/16S0R0J
RS1/10S0R0J
C
C
C
C
C
206
207
208
209
210
(A,47,77) CHIP ELECT.CAPACITOR
(B,53,55)
(A,48,70)
(A,50,70)
(A,47,70)
CEVW470M16
CKSRYB104K25
CKSRYB222K50
CKSRYB104K25
CKSRYB222K50
R
R
R
R
R
801
821
822
823
824
(A,54,85)
(A,42,83)
(A,39,86)
(A,36,86)
(A,37,86)
RS1/16S471J
RS1/16S103J
RS1/16S473J
RS1/16S153J
RS1/16S103J
C
C
C
C
C
211
212
213
214
215
(A,46,70)
(A,44,70)
(A,55,63)
(B,50,54)
(A,55,69) CHIP ELECT.CAPACITOR
CCSRCH560J50
CCSRCH560J50
CKSRYB104K25
CKSRYB104K25
CEVW470M16
R
R
R
R
R
851
852
853
881
882
(A,39,89)
(A,36,89)
(A,37,89)
(A,39,93)
(A,36,93)
RS1/16S473J
RS1/16S103J
RS1/16S103J
RS1/16S473J
RS1/16S103J
C
C
C
C
C
216
217
219
220
222
(A,46,62)
(A,42,62)
(A,36,61)
(A,31,58)
(A,29,53)
CKSRYB104K25
CKSRYB104K25
CKSRYB152K50
CKSRYB104K25
CKSRYB104K25
R
R
R
R
R
901
902
903
904
905
(A,39,128)
(B,40,131)
(A,43,128)
(A,41,128)
(A,44,128)
RS1/16S0R0J
RS1/16S0R0J
RS1/16S332J
RS1/16S682J
RS1/16S332J
C
C
C
C
C
223
224
225
226
227
(A,29,51)
(A,25,45)
(B,34,39)
(B,40,39)
(B,36,40)
CKSRYB104K25
CKSRYB104K25
CKSRYB104K25
CKSRYB103K50
CCSRCH221J50
R
R
R
R
R
906
907
908
909
910
(A,42,126)
(A,46,128)
(B,21,40)
(B,23,38)
(A,48,128)
RS1/16S682J
RS1/16S471J
RS1/16S332J
RS1/16S682J
RS1/16S221J
C
C
C
C
C
228
230
231
232
233
(B,39,37)
(B,37,35)
(B,42,35)
(B,46,36)
(B,49,33)
CKSRYB104K25
CKSRYB102K50
CKSRYB104K25
CKSRYB104K25
CKSRYB104K25
R
R
R
R
R
911
912
913
914
915
(A,50,128)
(A,53,128)
(A,55,128)
(A,56,128)
(A,57,128)
RS1/16S221J
RS1/16S0R0J
RS1/16S0R0J
RS1/16S103J
RS1/16S682J
C
C
C
C
C
234
235
236
237
239
(B,52,33)
(B,55,35)
(B,56,33)
(A,65,16) CHIP ELECT.CAPACITOR
(B,60,34)
CKSRYB104K25
CKSRYB104K25
CKSRYB104K25
CEVW221M4
CKSRYB104K25
R
R
R
R
916
917
920
932
(B,47,128)
(B,44,125)
(B,52,135)
(A,104,97)
RS1/16S223J
RS1/16S223J
RS1/16S332J
RS1/16S0R0J
C 240 (B,59,39)
C 241 (B,61,43)
C 243 (A,61,25)
CAPACITORS
B
C
D
E
F
50
CKSRYB104K25
CKSRYB104K25
CKSRYB105K10
PD-D6-J
1
2
3
4
5
Mark No.
6
Description
Part No.
7
Mark No.
8
Description
Part No.
C 244 (A,60,25)
C 245 (B,61,31)
CKSRYB104K25
CKSRYB104K25
C 739 (A,21,66)
C 751 (A,32,119)
CEVW101M16
CKSRYB105K10
C
C
C
C
C
246
249
250
253
254
(B,63,32)
(B,54,44)
(B,64,36)
(B,64,44)
(B,64,48)
CKSRYB104K25
CKSRYB104K25
CKSRYB103K50
CKSRYB104K25
CCSRCH391J50
C
C
C
C
C
CCSRCH471J50
CKSQYB225K10
CEVW101M16
CKSRYB104K25
CKSQYB104K16
C
C
C
C
C
255
256
257
258
259
(B,65,53)
(B,72,52)
(B,60,49)
(A,69,49)
(A,72,50)
CKSRYB474K10
CEVW100M16
CKSRYB104K25
CKSRYB473K50
CKSRYB473K50
C
C
C
C
C
260
261
262
263
264
(B,60,50)
(B,67,53)
(A,73,52)
(A,70,51)
(B,68,53)
CKSRYB104K25
CKSRYB105K10
CKSRYB104K25
CKSRYB105K10
CKSRYB104K25
C
C
C
C
C
265
266
267
268
269
(A,73,53)
(B,60,52)
(A,70,53)
(A,73,56)
(A,72,56)
CCSRCH220J50
CKSRYB104K25
CKSRYB102K50
CKSRYB104K25
CKSRYB333K16
C
C
C
C
C
271
272
273
281
282
(A,70,57)
(A,70,58)
(A,69,60)
(B,18,27) CHIP ELECT.CAPACITOR
(B,22,31)
CKSRYB104K25
CKSRYB104K25
CKSRYB104K25
CEVW221M4
CKSRYB105K10
C
C
C
C
C
283
284
285
286
287
(B,46,33)
(B,33,17)
(B,27,17)
(B,27,33)
(B,31,33)
CKSRYB104K25
CKSRYB104K25
CKSRYB104K25
CKSRYB104K25
CKSRYB104K25
C
C
C
C
C
288
289
290
296
298
(B,34,33)
(B,34,40)
(A,20,39)
(B,34,42)
(B,80,48)
CKSRYB104K25
CKSRYB105K10
CKSRYB104K25
CKSRYB102K50
CKSRYB105K10
C
C
C
C
C
299
309
310
343
344
(B,79,48)
(A,71,77) CHIP TZV CAPACITOR
(A,63,77) CHIP TZV CAPACITOR
(A,64,64)
(A,60,64)
CKSRYB102K50
VCH1260
VCH1260
CKSRYB105K10
CKSRYB105K10
C
C
C
C
C
345
346
347
371
372
(A,62,64)
(A,63,64)
(A,59,64)
(A,94,134)
(B,94,134)
CKSRYB105K10
CKSRYB105K10
CKSRYB105K10
CKSRYB104K25
CKSRYB104K25
C
C
C
C
C
373
374
701
711
712
(A,99,127) CHIP TZV CAPACITOR
(A,106,127) CHIP TZV CAPACITOR
(A,24,131)
(A,28,73)
(A,35,78)
VCH1260
VCH1260
CKSQYB105K16
CKSRYB105K10
CCSRCH471J50
C
C
C
C
C
713
732
733
734
735
(A,29,66)
(A,22,113) CHIP CERAMIC C.
(A,20,105) CHIP CERAMIC C.
(A,21,100)
(A,20,95) CHIP CERAMIC C.
CKSQYB225K10
DCH1165
DCH1165
CEVW101M16
DCH1165
C 736 (A,25,89)
C 737 (A,28,82)
C 738 (A,24,78) CHIP CERAMIC C.
CKSRYB104K25
CCSRCH121J50
DCH1165
752 (A,34,108)
753 (A,30,108)
761 (A,41,103)
801 (A,50,83)
1011CERAMIC CAPACITOR
C AJKB ASSY
MISCELLANEOUS
IC
IC
IC
IC
IC
1101(A,144,58)
1102(A,156,72)
1201(A,169,58)
1301(A,142,39)
1401(A,171,39)
IC
IC
IC
IC
IC
1501(A,97,24) AQE IC
1502(A,56,44) IC
1601(A,110,30) IC
1602(A,123,28) IC
1651(A,187,70) IC
PD0274A
TC74VHC125FTS1
TC74VHC157FTS1
TC74VHC157FTS1
TC74VHC08FTS1
IC
>IC
>IC
>IC
>IC
1701(A,196,84) IC
1804(A,115,60) IC
1831(A,86,54) REGULATOR IC
1832(A,71,44) REGURATOR (ADJ.)
1833(A,43,29) REGURATOR IC
TC74VHCU04FT
NJM78M05FA
BD7802FP
BA3948FP
BA00BC0WCP-V5
>IC
>IC
Q
Q
Q
1851(A,29,80) PROTECTOR(3A)
1852(A,36,74) PROTECTOR(4A)
1101(A,154,100) TRANSISTOR
1201(A,161,100) TRANSISTOR
1651(A,172,89) CHIP TRANSISTOR
AEK7015
AEK7018
2SD2114K
2SD2114K
UMH9N
Q
Q
Q
>Q
Q
1652(A,174,94) TRANSISTOR
1801(A,91,71) N-FET
1802(B,108,81) CHIP TRANSISTOR
1803(A,108,72) TRANSISTOR
1804(A,96,105) N-FET
2SA1576A
2SK246
2SC3906K
2SD1763A
2SK246
Q
>Q
D
D
D
1805(B,105,94) CHIP TRANSISTOR
1806(A,113,104) TRANSISTOR
1651(A,171,98) DIODE
1652(B,176,90) DIODE
1751(B,48,108) DIODE
2SA1514K
2SB1186A
DAP202U
DAN202U
1SS355
>D
>D
>D
>D
D
1801(A,65,98) SCHOTTKY DIODE
1802(A,65,90) SCHOTTKY DIODE
1803(A,60,114) SCHOTTKY DIODE
1804(A,60,106) SCHOTTKY DIODE
1805(B,94,81) DIODE
11EQS10
11EQS10
11EQS10
11EQS10
UDZS12(B)
D
D
D
D
D
1806(B,94,95) DIODE
1807(B,116,77) CHIP DIODE
1808(B,118,106) CHIP DIODE
1809(B,131,68) CHIP DIODE
1831(A,79,54) CHIP DIODE
UDZS12(B)
RB501V-40
RB501V-40
RB501V-40
RB501V-40
D
D
>D
>D
L
1832(A,72,56) CHIP DIODE
1833(B,50,28) CHIP DIODE
1851(A,49,84) BRIDGE DIODE
1852(A,41,64) DIODE
1701(A,203,90) COIL
RB501V-40
RB501V-40
S1VB20/F03
D3SBA20(B)
VTL1172
1702(A,191,94)
1301(A,152,20)
1302(A,130,50)
1401(A,181,20)
PTL1017
CTF1661
CTF1661
CTF1661
L
F
F
F
OP-AMP IC
OP-AMP IC
OP-AMP IC
D/A CONVERTER IC
D/A CONVERTER IC
COIL
INDUCTOR
INDUCTOR
INDUCTOR
NJM5532MD
NJM5532MD
NJM5532MD
PCM1738EG-3
PCM1738EG-3
6
B
7
8
C
D
E
F
51
PD-D6-J
5
A
1
Mark No.
A
B
2
Description
3
Part No.
Mark No.
F 1402(A,134,50) INDUCTOR
CTF1661
F 1701(B,197,102)
F 1702(B,199,100)
JA 1101(A,143,118)
JA 1201(A,163,118)
JA 1701(A,198,118)
CHIP MAGNET CORE
INDUCTOR
1P PIN JACK
1P PIN JACK
JACK
DTF1068
CTF1661
PKB1041
PKB1042
VKB1097
JA 1702(A,179,118) OPT. LINK OUT
JA 1751(A,33,116) JACK
JA 1752(A,43,116) JACK
KN1901(A,23,22) WRAPPING TERMINAL
KN1902(A,220,18) WRAPPING TERMINAL
VKS1002
RKN1004
RKN1004
VNF1084
VNF1084
KN1903(A,220,88) WRAPPING TERMINAL
KN1904(A,19,101) WRAPPING TERMINAL
KN1905(A,64,29) WRAPPING TERMINAL
CN1501(A,82,39) 17P CONNECTOR
CN1502(A,23,27) CONNECTOR
VNF1084
VNF1084
VNF1084
VKN1248
CKS3382
CN1503(A,23,59) CONNECTOR
CN1851(A,218,48) CONNECTOR
SCREW
SCREW
HEAT SINK
B4B-PH
CKS3380
BBZ30P080FCC
PMH30P080FCC
PNS1043
RESISTORS
C
D
E
F
R
R
R
R
R
1103(A,148,68)
1104(A,144,73)
1105(A,148,70)
1106(A,148,71) CHIP METAL FILM R
1107(A,148,73) CHIP METAL FILM R
RN1/16SE1201D
RN1/16SE1201D
RN1/16SE1201D
RN1/16SE1801D
RN1/16SE1801D
R
R
R
R
R
1108(A,148,74)
1109(B,154,95)
1110(A,168,101)
1111(B,154,97)
1112(B,154,102)
RN1/16SE1201D
RS1/16S223J
RS1/16S102J
RS1/16S751J
RS1/16S221J
R
R
R
R
R
1114(A,152,62) CARBON FILM RESISTOR
1115(A,135,62) CARBON FILM RESISTOR
1203(A,168,73)
1204(A,164,68)
1205(A,164,70)
PCN1041
PCN1041
RN1/16SE1201D
RN1/16SE1201D
RN1/16SE1201D
R
R
R
R
R
1206(A,164,71) CHIP METAL FILM R
1207(A,164,73) CHIP METAL FILM R
1208(A,164,74)
1209(B,158,95)
1210(A,168,99)
RN1/16SE1801D
RN1/16SE1801D
RN1/16SE1201D
RS1/16S223J
RS1/16S102J
R
R
R
R
R
1211(B,158,97)
1212(B,161,102)
1214(A,177,62) CARBON FILM RESISTOR
1215(A,160,62) CARBON FILM RESISTOR
1301(A,138,29)
RS1/16S751J
RS1/16S221J
PCN1041
PCN1041
RS1/16S220J
R
R
R
R
R
1302(A,140,29)
1303(B,136,44)
1401(A,167,29)
1402(A,169,30)
1403(B,170,42)
RS1/16S470J
RN1/16SE1602D
RS1/16S220J
RS1/16S470J
RN1/16SE1602D
R
R
R
R
R
1501(A,104,44)
1502(A,89,24)
1503(A,101,31)
1504(A,98,31)
1505(A,102,28)
RS1/10S4R7J
RS1/16S220J
RS1/16S220J
RS1/16S220J
RS1/16S220J
R 1507(B,90,36)
4
Description
Part No.
R
R
R
R
1508(B,90,34)
1509(B,90,31)
1510(B,90,29)
1511(B,87,24)
RS1/16S680J
RS1/16S680J
RS1/16S680J
RS1/16S100J
R
R
R
R
R
1512(B,83,18)
1513(B,83,20)
1515(B,88,41)
1516(A,29,32)
1517(A,29,33)
RS1/16S100J
RS1/16S100J
RS1/16S680J
RS1/16S220J
RS1/16S220J
R
R
R
R
R
1551(A,91,29)
1552(A,95,31)
1553(A,94,31)
1560(A,125,22)
1602(A,109,23)
RS1/16S220J
RS1/16S220J
RS1/16S220J
RS1/16S220J
RS1/16S560J
R
R
R
R
R
1604(A,114,25)
1605(A,112,23)
1606(A,108,37)
1607(A,109,37)
1609(A,111,37)
RS1/16S560J
RS1/16S220J
RS1/16S220J
RS1/16S100J
RS1/16S101J
R
R
R
R
R
1610(A,112,37)
1612(A,114,35)
1614(A,122,21)
1616(A,128,22)
1617(A,120,35)
RS1/16S100J
RS1/16S560J
RS1/16S560J
RS1/16S560J
RS1/16S220J
R
R
R
R
R
1618(A,122,35)
1620(A,123,35)
1621(A,125,35)
1623(A,127,31)
1651(A,169,83)
RS1/16S100J
RS1/16S101J
RS1/16S100J
RS1/16S560J
RS1/10S0R0J
R
R
R
R
R
1652(A,175,91)
1653(B,170,84)
1654(B,180,89)
1655(A,171,92)
1656(B,180,91)
RS1/10S332J
RS1/16S472J
RS1/16S102J
RS1/16S103J
RS1/16S102J
R
R
R
R
R
1661(A,163,31)
1662(A,162,33)
1701(A,193,75)
1702(A,199,78)
1703(A,202,83)
RS1/16S332J
RS1/16S682J
RS1/10S0R0J
RS1/16S0R0J
RS1/16S0R0J
R
R
R
R
R
1704(A,203,85)
1705(A,191,88)
1706(B,192,90)
1751
1752
RS1/16S220J
RS1/16S470J
RS1/16S750J
RS1/16S0R0J
RS1/16S0R0J
R
R
R
R
R
1801(A,48,95) CARBON FILM RESISTOR
1802(B,111,75)
1803(B,101,83)
1804(B,116,106)
1805(B,101,92)
RD1/4MUF4R7J
RS1/16S681J
RS1/16S331J
RS1/16S681J
RS1/16S331J
R
R
R
R
R
1806(A,130,103) METAL OXIDE RESISTOR
1807(A,136,103) METAL OXIDE RESISTOR
1808(B,24,93)
1809(B,26,93)
1810(B,32,90)
RS2LMF331J
RS2LMF331J
RS1/10S0R0J
RS1/10S0R0J
RS1/10S0R0J
R
R
R
R
R
1811(B,34,90)
1835(A,73,51)
1836(A,67,51)
1837(A,69,52)
1839(B,46,33)
RS1/10S0R0J
RS1/16S102J
RS1/16S3302F
RS1/16S1203F
RS1/16S102J
R 1840(B,42,20)
RS1/16S3902F
RS1/16S680J
52
PD-D6-J
1
2
3
4
5
Mark No.
6
Description
R 1841(B,46,18)
R 1842(B,46,20)
Part No.
RS1/16S334J
RS1/16S334J
CAPACITORS
C
C
C
C
C
1104(A,150,57)
1105(A,137,58)
1106(A,143,54)
1107(A,137,65)
1108(A,146,62)
CCSRCH152J50
CCSRCH152J50
CKSRYB104K16
CEAT101M16
CKSRYB104K16
C
C
C
C
C
1109(A,146,65)
1110(A,146,72)
1111(A,150,70)
1112(A,150,73)
1113(A,150,90)
CEAT101M16
CCSRCH122J50
CCSRCH471J50
CCSRCH471J50
VCH1255
C
C
C
C
C
1115(A,159,76)
1116(A,163,79)
1117(A,155,68)
1118(A,154,79)
1204(A,175,57)
CKSRYB104K16
CEAT101M16
CKSRYB104K16
CEAT101M16
CCSRCH152J50
C
C
C
C
C
1205(A,162,58)
1206(A,168,54)
1207(A,162,65)
1208(A,171,62)
1209(A,171,65)
CCSRCH152J50
CKSRYB104K16
CEAT101M16
CKSRYB104K16
CEAT101M16
C
C
C
C
C
1210(A,166,72)
1211(A,162,70)
1212(A,162,73)
1213(A,163,90)
1301(A,152,31) ELECT. CAPACITOR
CCSRCH122J50
CCSRCH471J50
CCSRCH471J50
VCH1255
CEAT471M6R3
C
C
C
C
C
1302(A,142,31)
1303(A,135,35)
1305(A,133,46) OS CAPACITOR
1307(A,139,49) ELECT. CAPACITOR
1308(A,150,45) ELECT. CAPACITOR
CKSRYF105Z10
CKSRYB104K16
ACH7203
VCH1249
VCH1249
C
C
C
C
C
1309(B,144,38)
1310(A,148,34)
1401(A,181,31) ELECT. CAPACITOR
1402(A,171,31)
1403(A,164,35)
CCSRCH471J50
CKSRYB103K50
CEAT471M6R3
CKSRYF105Z10
CKSRYB104K16
C
C
C
C
C
1405(A,162,45) OS CAPACITOR
1407(A,168,49) ELECT. CAPACITOR
1408(A,180,45) ELECT. CAPACITOR
1409(B,168,38)
1410(A,177,34)
ACH7203
VCH1249
VCH1249
CCSRCH471J50
CKSRYB103K50
C
C
C
C
C
1501(A,104,38) ELECT. CAPACITOR
1502(A,91,26)
1503(A,91,23)
1504(A,102,24)
1505(A,60,42)
VCH1248
CKSRYB104K16
CKSRYF105Z10
CKSRYF105Z10
CKSRYB104K16
C
C
C
C
C
1506(A,91,18)
1511(B,16,39)
1601(A,106,33)
1602(A,107,43)
1603(A,119,30)
CKSRYB103K50
CKSRYB104K16
CKSRYF105Z10
CEAT470M35
CKSRYF105Z10
C
C
C
C
C
1605(A,120,43)
1652(A,190,68)
1704(A,193,80)
1705(A,190,80) ELECT. CAPACITOR
1706(B,178,105)
CEAT470M35
CKSRYB104K16
CKSRYB104K16
VCH1248
CKSRYF105Z10
7
Mark No.
8
Description
Part No.
C
C
C
C
C
1707(B,178,107)
1708(A,183,99)
1709(B,205,88)
1710(A,208,86)
1717(B,197,109)
CCSRCH102J50
CEAT470M35
CKSRYB103K50
CEAT470M35
CKSRYB102K50
C
C
C
C
C
1751(B,39,109)
1752(B,37,109)
1753(B,50,111)
1801(A,54,90) AUDIO FILM CAPACITOR
1802(A,43,90) AUDIO FILM CAPACITOR
CKSRYF105Z10
CKSRYB103K50
CKSRYB104K16
ACE7063
ACE7063
C
C
C
C
C
1803(A,80,72)
1804(A,80,95)
1805(A,96,81)
1806(A,91,95)
1807(A,132,81)
PCH1156
PCH1156
CEAT101M16
CEAT101M16
CEAT101M25
C
C
C
C
C
1808(A,139,85)
1809(B,116,64)
1811(A,131,64)
1813(A,128,71) ELECT. CAPACITOR
1831(A,81,61)
CEAT101M25
CKSRYB104K16
CKSRYF105Z10
CEHAZL102M16
CKSQYF105Z25
C
C
C
C
C
1832(A,82,46)
1834(A,74,53)
1835(A,64,56)
1837(B,46,35)
1838(A,45,14)
CEAT471M16
CKSQYF105Z25
CEAT101M16
CKSQYF105Z25
CEAT101M16
6
B
C
C 1852(A,61,81) ELECT. CAPACITOR
C 1854(A,53,64) ELECT. CAPACITOR
C 1901(B,118,56)
CEAT332M25
CEAT472M25
CKSRYB104K16
D LCD ASSY
MISCELLANEOUS
IC
Q
Q
Q
Q
2101(B,132,210) CPU
2101(B,75,193) TRANSISTOR
2102(B,179,189) TRANSISTOR
2103(B,181,184) TRANSISTOR
2104(B,56,178) TRANSISTOR
PDC148A
RT1N241M
RT1N241M
2SA1577
RT1N241M
Q
Q
Q
Q
Q
2106(B,71,227) DIGITAL TR(SC-70)
2108(B,172,218) TRANSISTOR
2201(B,61,212) TRANSISTOR
2202(B,60,204) TRANSISTOR
2203(B,61,196) TRANSISTOR
RT1N431M
2SC4097
2SC4081
2SC4081
2SC4081
Q
Q
Q
D
D
2204(B,48,220)
2401(B,56,183)
2402(B,50,188)
2101(A,50,204)
2102(A,50,180)
UMH1N
RT1P241M
RT1N431M
SLI-343URCW(RST)
SLR-343VC(NPQ)
D
D
D
D
D
2103(B,170,212) DIODE
2105(B,119,226) DIODE
2206(A,58,210) LED(WHITE)
2207(A,58,204) LED(WHITE)
2208(A,58,197) LED(WHITE)
1SS355
1SS355
NSPW510BS-2224
NSPW510BS-2224
NSPW510BS-2224
D
D
D
L
L
2209(B,49,214) DIODE
2210(B,53,217) DIODE
2402(B,44,197) DIODE
2101(B,115,226) INDUCTOR
2102(B,175,207) INDUCTOR
DAN217
1SS355
1SS355
LCYA220J2520
CTF1389
TRANSISTOR
DIGITAL TR(SC-70)
DIGITAL TR(SC-70)
LED(RED)
LED(RED)
L 2103(B,154,202) INDUCTOR
L 2104(B,154,200) INDUCTOR
L 2105(B,149,201) INDUCTOR
D
53
7
8
E
F
CTF1389
CTF1389
CTF1389
PD-D6-J
5
A
1
Mark No.
A
2
Description
Part No.
F 2201(B,185,185) INDUCTOR
J 2102(A,86,229) CONNECTOR ASS'Y
CTF1661
PF04PG-C12
J 2104(A,188,185) JUMPER WIRE
KN2101(A,71,178) WRAPPING TERMINAL
V 2201(A,125,185) LCD MODULE
X 2101(A,119,221) CERAMIC RESONATOR
CN2101(A,58,227) CONNECTOR 7P
D20PYY0320E
VNF1084
AAV7111
ASS7034
52492-0720
CN2105(A,158,225) CONNECTOR
CN2106(A,189,218) CONNECTOR
LCD COVER R(PLS)
3P CABLE HOLDER
8P CABLE HOLDER
9607S-17F
CKS3829
XMR3094
51048-0300
51048-0800
LCD LT COND. (PLS)
LCD HOLDER (PLS)
LCD COVER L(PLS)
DIFFUSSION SHEET
2401(A,21,180) REMOTE RECEIVER UNIT
B
3
Mark No.
XAK3494
XMR3092
XMR3093
XAK3521
GP1UM28XK0VF
RESISTORS
C
D
E
F
4
Description
2149(B,143,198)
2150(B,141,196)
2151(B,141,201)
2153(B,78,212)
2154(B,69,223)
RS1/16S221J
RS1/16S221J
RS1/16S221J
RS1/16S473J
RS1/16S222J
R
R
R
R
R
2155(B,105,231)
2160(B,166,214)
2161(B,116,194)
2162(B,100,202)
2163(B,92,201)
RS1/16S101J
RS1/16S221J
RS1/16S221J
RS1/16S221J
RS1/16S221J
R
R
R
R
R
2165(B,71,190)
2171(B,90,206)
2175(B,183,232)
2210(B,54,210)
2211(B,63,213)
RS1/16S221J
RS1/16S473J
RS1/16S0R0J
RS1/16S102J
RS1/16S620J
R
R
R
R
R
2212(B,65,208)
2213(B,64,205)
2214(B,66,205)
2215(B,62,200)
2216(B,65,199)
RS1/16S0R0J
RS1/16S620J
RS1/16S0R0J
RS1/16S620J
RS1/16S0R0J
R
R
R
R
R
2101(B,48,201)
2103(B,183,194)
2104(B,81,224)
2105(B,107,201)
2106(B,76,205)
RS1/16S102J
RS1/16S473J
RS1/16S104J
RS1/16S103J
RS1/16S221J
R
R
R
R
R
2107(B,107,203)
2108(B,113,202)
2110(B,91,191)
2111(B,105,191)
2112(B,151,201)
RS1/16S221J
RS1/16S221J
RS1/16S221J
RS1/16S221J
RS1/16S473J
R
R
R
R
R
2113(B,175,184)
2114(B,177,185)
2115(B,156,192)
2116(B,115,198)
2117(B,107,208)
RS1/16S102J
RS1/16S223J
RS1/16S221J
RS1/16S221J
RS1/16S221J
R
R
R
R
R
2118(B,107,210)
2121(B,119,218)
2122(B,123,226)
2123(B,126,229)
2125(B,106,219)
RS1/16S221J
RS1/16S105J
RS1/16S221J
RS1/16S221J
RS1/16S473J
R
R
R
R
R
2126(B,120,229)
2127(B,127,233)
2128(B,130,229)
2129(B,127,231)
2130(B,120,193)
RS1/16S105J
RS1/16S221J
RS1/16S221J
RS1/16S221J
RS1/16S221J
R
R
R
R
R
2131(B,102,193)
2132(B,154,179)
2133(B,166,219)
2134(B,166,216)
2135(B,53,181)
RS1/16S221J
RS1/16S221J
RS1/16S221J
RS1/16S221J
RS1/16S271J
R
R
R
R
R
2136(B,122,233)
2137(B,118,231)
2138(B,124,233)
2140(B,123,194)
2141(B,149,217)
RS1/16S473J
RS1/16S473J
RS1/16S473J
RS1/16S221J
RS1/16S221J
E PLED ASSY
R
R
R
R
R
2142(B,152,216)
2143(B,157,207)
2146(B,159,204)
2147(B,163,204)
2148(B,139,198)
RS1/16S221J
RS1/16S221J
RS1/16S103J
RS1/16S103J
RS1/16S221J
RESISTORS
R 2219(B,126,188)
R 2401(B,43,208)
R 2403(B,45,200)
RS1/16S182J
RS1/16S471J
RS1/16S223J
CAPACITORS
C
C
C
C
C
2101(B,81,222)
2103(B,122,198)
2109(B,122,229)
2110(B,124,229)
2112(B,149,220)
CKSRYB102K50
CKSRYB104K16
CKSRYB103K50
CKSRYB103K50
CKSRYB104K16
C
C
C
C
C
2113(B,143,203)
2114(B,72,222)
2115(B,112,216)
2201(B,129,188)
2203(B,103,181)
CKSRYB104K16
CKSRYB103K50
CKSRYB104K16
CKSRYB104K16
CKSRYB104K16
C
C
C
C
C
2204(B,113,181)
2205(B,151,180)
2206(B,128,180)
2207(B,107,181)
2209(B,174,179)
CCSRCH220J50
CCSRCH220J50
CCSRCH220J50
CCSRCH220J50
CKSRYB104K16
C
C
C
C
C
2210(A,176,180)
2216(B,118,223)
2217(B,96,229)
2219(A,73,230)
2220(A,110,232)
CEAL101M10
CKSRYB104K16
CKSRYB104K16
CEAT100M50
ACH1246
C 2226(B,174,220)
C 2401(B,25,182)
C 2402(A,49,194) ELECT. CAPACITOR
CKSRYF105Z10
CKSRYB104K16
CEAT470M35
MISCELLANEOUS
D 2601(A,27,217) LED(BLUE)
R 2601(B,32,221)
SLR343BC4T
RS1/16S271J
CAPACITORS
C 2602(A,22,223)
54
Part No.
R
R
R
R
R
CEJQ470M16
PD-D6-J
1
2
3
4
5
6
Mark No.
Description
Part No.
7
Mark No.
R 15
F MNSW ASSY
TRANSISTOR
POWER SWITCH
AMP U-P CONNECTOR
CONNECTOR
CONNECTOR
Description
(B,21,88)
Part No.
RS1/16S103J
CAPACITORS
MISCELLANEOUS
Q 2501(B,223,30)
>S 2501(A,219,31)
>CN2501(A,153,22)
CN2502(A,226,19)
CN2503(A,210,13)
8
RT1N241M
VSA1005
VKN2024
S2B-PH
B4B-PH
>C 12
C 15
C 16
(A,122,162) FILM CAPACITOR
(A,25,88) ELECT. CAPACITOR
(A,25,110)
A
ACE7013
CEAT102M25
CEAT221M16
J TRANS ASSY (KUXJ/CA type)
MISCELLANEOUS
G KEY ASSY
>J 51
J 52
(A,192,166) 2P CONECTOR ASSY
(A,193,89) 7P CONNECTOR ASSY
PKP1018
PKP1017
MISCELLANEOUS
S 2301(A,204,193) SWITCH
S 2302(A,224,193) SWITCH
2301(A,202,222) PCB BINDER
3P CABLE HOLDER
VSG1024
VSG1024
VEF1040
51048-0300
RESISTORS
B
RESISTORS
R 51
R 52
(A,210,91) CARBON FILM RESISTOR RD1/4MUF4R7J
(A,193,97) CARBON FILM RESISTOR RD1/4MUF4R7J
CAPACITORS
R 2301(B,203,190)
R 2302(B,216,193)
RS1/16S103J
RS1/16S103J
H CONECTOR ASSY
C
C
C
C
51
52
53
54
(A,213,98) AUDIO FILM CAPACITOR
(A,205,92) AUDIO FILM CAPACITOR
(A,196,103)
(A,186,100)
ACE7060
ACE7060
CFTLA824J50
CFTLA824J50
MISCELLANEOUS
KN2701(A,113,34) WRAPPING TERMINAL
CN2701(A,94,28) CONNECTOR
CN2702(A,55,16) CONNECTOR
CN2703(A,110,30) CONNECTOR
CN2704(A,61,13) CONNECTOR
C
VNF1084
VKN1205
CKS3380
VKN1191
B2P-SHF-1AA
CAPACITORS
C 2701(B,49,24)
CKSRYB104K16
I PRIMARY ASSY (KUXJ/CA type)
D
MISCELLANEOUS
>IC
Q
>D
D
D
11
11
11
12
13
(A,26,99)
(B,26,79)
(A,32,99)
(B,39,73)
(B,39,65)
D
D
>L
H
H
14
15
11
11
12
(B,29,91) DIODE
(B,21,85) DIODE
(A,122,137) LINE FILTER
(A,144,113) FUSE CLIP
(A,144,133) FUSE CLIP
1SS355
UDZS5R1(B)
XTF3004
AKR7001
AKR7001
J 11
>J 12
>J 13
>RY11
>T 11
(A,17,100) CONNECTOR ASSY
(A,126,116) AC INLET ASSY
(A,130,162) 2P CONECTOR ASSY
(A,65,71) JOE LOWPOWER RELAY
(A,65,110) POWER TRANSFORMER
PF04PG-C07
PKP1014
PKP1015
ASR7013
ATT7079
>CN13
13
11
12
(A,70,165) CONNECTOR
(A,118,109) PCB BINDER
(A,15,148) PCB BINDER
(A,30,168) PCB BINDER
B2P3-VH
VEF1040
VEF1040
VEF1040
REGULATOR IC
TRANSISTOR
BRIDGE DIODE
DIODE
DIODE
NJM78M56FA
RT1N241M
S1VB20/F03
1SS355
1SS355
E
F
RESISTORS
R 12
R 14
(A,32,88) CARBON FILM RESISTOR RD1/4MUF220J
(B,29,85)
RS1/16S332J
55
PD-D6-J
5
6
7
8
1
2
3
4
6. ADJUSTMENT
6.1 ADJUSTMENT ITEMS AND LOCATION
A
Adjustment Items
Adjustment Points (Mechanism Part)
[Mechanism Part]
Cautions: After adjustment, adjustment screw locks with the
Screw tight.
1 Tangential and Radial Height Coarse Adjustment
2 DVD (CD) Error Rate Adjustment
1 2
Tangential
adjustment
screw
[Electrical Part]
1 2
Radial
adjustment
screw
Electrical adjustments are not required.
B
C
D
6.2 JIGS AND MEASURING INSTRUMENTS
E
Screwdriver (large)
Screwdriver (medium)
Test mode remote control
unit (GGF1381)
Screw tight
(GYL1001)
Precise screwdriver
F
DVD test disc
(GGV1025)
56
Soldering iron
PD-D6-J
1
2
3
4
5
6
7
8
6.3 NECESSARY ADJUSTMENT POINTS
When
Adjustment Points
A
Exchange Parts of Mechanism
Mechanical ~, Ÿ
point
Exchange the 05SD Pickup Assy
∗ After adjustment, screw locks
with the Screw tight.
Electric
point
Mechanical
point
Exchange the Traverse Mechanism
Assy-S
B
Electric
point
∗ After adjustment, screw locks
with the Screw tight.
Mechanical Ÿ
point
Exchange the Spindle Motor
Electric
point
C
Exchange PCB Assy
Mechanical
point
Exchange PC Board
LOAB and DVDM ASSYS
Electric
point
D
E
F
57
PD-D6-J
5
6
7
8
1
2
3
4
6.4 TEST MODE
A
POWER ON
How to display the error rate
Power-on in DVD mode
With the AC power off, turn the AC power on by pulling up
Pin 44 of IC2101 with 5 V (by short-circuiting JP2101).
(See next page. )
POWER
B
Note: When the unit is turned on in DVD mode, "-DVD-" is
indicated on the LCD.
ON
DISC SET
<TRAY OPEN>
<TRAY CLOSE>
OPEN/CLOSE
OPEN/CLOSE
(Player)
(Player)
DVD disc
C
TEST MODE: PLAY
An error rate is displayed
<PLAY>
Press the play key
(
) of the normal
remote control unit.
D
5
ESC
GGF1381
Test mode
remote control
unit
9 9 0 E – 6
The error rate is displayed as above.
But this means " 9.90E – 6 ".
Notes:
• The audio signal are outputted during the test mode.
• The SKIP key and the SCAN key are effective during the test mode.
Note:
Even if you intend to continuously
use the unit after displaying the error
rate, be sure to turn the power off then
back on
E
TEST MODE: OFF
ESC
POWER
GGF1381
Test mode
remote control
unit
F
OFF
58
PD-D6-J
1
2
3
4
LCD ASSY
W185
GNDD
1
Short
UPPER SIDE
JP2102
W187
GNDD
W186
CN2105
W146
C
JP2101
W164
C2210
W189
17
W190
W192 GNDD
UPPER SIDE
5.SDATA
4.XDVDRST
3.XREADY
2.DVDROWER
1,8,9.GNDD
1
59
PD-D6-J
8
15
15.TROUT
W188
14.TRGAIN
13.TRIN
12.VDET
11.SPDIF_RQ
8.MDATA
7.ACK
6.SCLK
W191
D
W169
84 V+56ST
GNDD
W161 V+5U
J2105
W166
CN2106
W168 GNDD
J2104
7
6
5
W165 V+5U
V+5U
W163
1
1.KEY1
2.VE+5
3.GNDU
W167
W147
V+5U
JP2101
ss'y
2.SRIN
1 IROUT
17.XDACRST
16.SYSPOW
15.AC
14.GNDD
13.GNDD
12.V+58U
11.GNDD
10.V+56ST
9.XSYSMUTE
8.XDFRST
7.XDFCS
6.XDFDT
5.XDFCLK
4.GNDD
3.GNDD
D
8
7
6
5
Service Test mode connecting point
A
B
SIDE A
E
F
1
2
3
4
6.5 MECHANISM ADJUSTMENT
A
1 Tangential and Radial Height Coarse Adjustment
START
05SD Pickup Assy
• Remove the 05SD Pickup Assy from the Traverse Mechanism Assy-S.
• Remove the joint and the joint spring of the 05SD Pickup Assy.
Note:
Before removing the flexible cable for the
pickup, soldering of the pickup circuit is
necessary.
For details, see "7.1.5 DISASSEMBLY".
B
Joint
Joint Spring
• Pass through the guide shaft to a new 05SD Pickup Assy.
• Attach it to the Traverse Mechanism Assy-S.
05SD Pickup Assy
C
Guide Shaft
D
• Put the joint between the Tangential (or Radial) adjustment screw and the mechanism base
and turn each screw to adjust the height.
(Refer to "6.1 ADJUSTMENT ITEMS AND LOCATION".)
Joint
7.5mm
Mechanism base
E
• Attach the Traverse Mechanism Assy-S to the 05 LOADER Assy.
• Turn it over and attach the joint and the joint spring.
• Arrange the flexible cables.
(Refer to "7.1.5 DISASSEMBLY".)
F
60
PD-D6-J
1
2
3
4
5
6
7
8
• Play the DVD test disc
at inner track
(around #30000) \(Play title1)
* At stop mode, press 1 , then ENTER
key of the set remote control.
2 DVD Error Rate Adjustment
Notes:
• Use disc: GGV1025
9 9 0 E – 6
The error rate is displayed as above.
But this means " 9.90E – 6 ".
START
Traverse Mechanism
Assy-S
Adjust the radial adjustment
screw so that
ERROR RATE becomes
around "5E-4".
A
• Play the DVD test disc
at inner track
• Display ERROR RATE
on the LCD display
ESC
5
A
Traverse Mechanism
Assy-S
Fasten the radial
adjustment screw so that
ERROR RATE becomes
around "1E-3".
B
B
1E-3
C
ERROR
RATE
A
5E-4
• Unfasten the radial adjustment screw
by 90 degrees step till ERROR RATE
C
becomes around "1E-3" again .
• Record the number of rotation (N1).
B
A
Best point
(memorizing how much the screw was rotated.)
• Fasten the radial adjustment screw
till the number of rotation becomes
harf of N1.
Best Radial point
Anticlock wise
Clock wise
Rotation of Radial screw
and Tangential screw
C
ESC
Player
Service mode end
• Play the DVD test disc at outer track
(around #200000) \ (Play title 22)
* At stop mode, press 2 , 2 , then
ENTER key of the set remote control.
Turn the POWER OFF in
case of NG once, and
perform the adjustment
once again.
ESC
5
N
G
If error rate is OK,
locks a root of
tangential and radial
adjustment screws with
the Screw tight.
Screw tight: GYL1001
D
\ Service mode
Traverse Mechanism
Assy-S
Fasten the tangential
adjustment screw so that
ERROR RATE becomes
around "1E-3".
B
CHECK
OK
In this check, the error rate
that is less than "5E-5"is
better.
Disc playback normally.
• The measurement of
block error rate
ESC
5
ESC
Service mode end
• Unfasten the tangential screw
by 90 degrees step till ERROR RATE
becomes around "1E-3" again .
C
• Record the number of rotation (N1).
• Fasten the tangential adjustment screw
till the number of rotation becomes
harf of N1.
Best tangential point
6
F
61
PD-D6-J
5
E
7
8
1
2
3
4
7. GENERAL INFORMATION
7.1 DIAGNOSIS
7.1.1 TEST MODE
A
The Version Display Mode Functional Specification
Mechanical control computer
How to display the version of the mechanical control computer
1 Power-on in DVD mode
With the AC power off, turn the AC power on by pulling up Pin 44 of IC2101 with 5 V (by short-circuiting JP2101).
Note: When the unit is turned on in DVD mode, "-DVD-" is indicated on the LCD.
2 Displaying the version of the mechanical control computer
Press the [ESC] then the [CHAP] key on the remote control unit for DVD Test mode to indicate the version of the
mechanical control computer.
Ex.
(1) : This means that the part number is " AYW7153 ".
7 1 5 3 1 – 0 6
(2) : This means that the version is " 1.06 ".
(1)
(2)
B
3 Canceling version display
• Press the [ESC] key on the remote control unit.
• Press the [POWER] button to turn the unit off.
Note: Even if you intend to continuously use the unit after displaying the error rate, be sure to turn the power off then back
on again.
C
System control computer
Displaying the version of the system control computer
1 Displaying the version of the system control computer
With the unit on, press and hold the [3/7] key on the main unit for 8 seconds. The version (part number) of the system
control computer will be displayed.
Ex.
P D C 1 4 8 A
2 Canceling version display
The version display will automatically disappear after a while.
D
D
LCD ASSY
JP2101
W185
GNDD
2.SRIN
1 IROUT
JP2102
JP2101
W163
V+5U
17
W190
CN2106
W192 GNDD
5.SDATA
4.XDVDRST
3.XREADY
2.DVDROWER
1,8,9.GNDD
62
1
1.KEY1
2.VE+5
3.GNDU
W189
W169
W191
F
15.TROUT
W188
14.TRGAIN
13.TRIN
12.VDET
11.SPDIF_RQ
8.MDATA
7.ACK
6.SCLK
W167
W168 GNDD
J2104
W187
GNDD
C2210
W166
W147
V+5U
W186
W164
CN2105
W146
W165 V+5U
1
Short
UPPER SIDE
17.XDACRST
16.SYSPOW
15.AC
14.GNDD
13.GNDD
12.V+58U
11.GNDD
10.V+56ST
9.XSYSMUTE
8.XDFRST
7.XDFCS
6.XDFDT
5.XDFCLK
4.GNDD
3.GNDD
J2105
84 V+56ST
GNDD
E
W161 V+5U
ss'y
SIDE A
1
UPPER SIDE
PD-D6-J
1
2
3
4
15
5
6
7
8
7.1.2 METHOD FOR DIAGNOSING DEGRADATION OF THE LDS ON THE PICKUP ASSY
Case when this diagnosis is required :
When playback of any disc, including a test disc (DVD: GGV1025, CD: STD-905), won't play or doesn't play
A
How to diagnose
In the case mentioned above, degradation of the laser diodes (LDs) mounted on the 05SD Pickup Assy is suspected.
Measure the voltage between the two ends of one of the resistors mentioned below.
No playback of a CD :
Measure the voltage between the both ends of R321 or R326 on the DVDM
Assy. If the voltage is 0.4 V or higher, the 780-nm LD is degraded.
If the measurements show degradation
of an LD, replace the 05SD Pickup
Assy.
No playback of a DVD (Test Mode), No playback of a SACD :
B
Measure the voltage between the both ends of R322 or R325 on the DVDM
Assy. If the voltage is 0.4 V or higher, the 650-nm LD is degraded.
05SD PICKUP ASSY
C
CN101
BOTTOM SIDE
UP SIDE
UP SIDE
BOTTOM SIDE
1
12
CN102
1
4
24
1
C371
CN101
R904
C152
R940
BOTTOM SIDE
1
C151
L308
L309
3.3V
3.3V
C144
5V
Q881 C
D881 C752
C143
LD_CD
Q307
R504
1
C508
Q
Q
C502
D
R750
L751
R734
D801
R801
R713
R737
C801
D C712
3.3V
C310
R207
C215
R214
C213
C206
5
4
1
IC711
C204
A
8
64
1
R59
25
65
R20
C509
C202
R595
C713
R711
Q506
R520
C503
1
4
C343
C346
C345
C344
C347
C506
C505 R502
R594
IC501
R310
C320
C309
R505
7
6.5V
R322
R714
C221
R602
R601
E
C133
C142
C141
1
LD_DVD
R325
R326
Q308
C203
R321
R134
R132
R131
Q801
R712
R509
R508
R507
C1002
5
GNDM
22
R136
R135
R133
C102
C161
C146
C145
5
1
R931
R932
R933
R934
R935
R936
R937
R938
R939
R906
R919
IC101
C131
C132
C761
3
R736
4
E
9
8V
2
1
R313
R318
Q305 R315
C103
17
CN953
C153
R151
R153
R761
D
R506
CN901
C101
R762
R751
C751
LF
4
R373
C373
C374
3
5
Q304
1
R314
R915
R914
R913
R912
R911
R910
R918
R907
R905
R903
C104
R152
R154
IC761
D751
R731
Front side
CN103
C140
GNDD
DVDM ASSY
R901
Q702
B
SIDE A
F
63
PD-D6-J
5
6
7
8
1
2
3
4
7.1.3 TROUBLE SHOOTING
Start
(Power → ON)
A
Does
the LCD light?
No
Yes
Does
the pure audio
or dimmer function
operate?
Yes
Are the
indications on
the LCD correct?
No
Yes
Does the tray
open?
C
No
• Check the FU1.
• Check the connection between the PRIMARY
and AJKB (4 pin) Assys.
• Check the connection between the AJKB and
LCD Assys (17-pin FFC).
• Check that the voltage at J11 3 is 5.6 V.
No
Yes
Cancel the pure audio
or dimmer function.
B
The LCD
display goes dark,
and the pure audio
LED starts flashing.
No
• Check the connection between the AJKB and CONNECTOR Assys (15-pin FFC).
• Check the connection between the CONNECTOR and DVDM Assys (29-pin FFC).
• Check the voltages at V+12A, V+5A, V+9D, and V+6R5V.
• Check that the voltage at V2201 1
is 4.4 V and that that at V2201 2
is 5 V.
• Are any data transmitted on the
LCD communication line (LCCDT,
LCDCK, LCDCS, LCDRS) when
the voltage is switched between 0
and 5 V?
• Are H and L switched when BLOFF
or DIMMER functions?
[V+12V system]
Check that the voltage
at C1803(+) is
+17 V.
No
Yes
[V+5A]
Check
that the voltage
at C1805(+) is
+12 V.
No
Check the connections at
D1801, D1802, and CN1801.
No
• Is D1809 short-circuited?
• Are the pins bridged at
IC1301 or IC1401?
Replace D1805 and Q1801,
in that order.
Yes
Refer to Addendum No. 1.
Replace D1807 and Q1803,
in that order.
Yes
Yes
Check if the pins are short-circuited
at IC1101, IC1201, or IC1102.
Does
the focus function
operate?
No
Refer to Addendum No. 2.
[V+9D system]
Check that the voltage
at C1852(+) is
+8.3 V.
Yes
No
Does
the spindle
rotate?
No
Replace IC1851.
Refer to Addendum No. 3.
• Check the connections at D1851 and CN1801.
• Check the connection between the AJKB
and CONNECTOR Assys (15-pin FFC).
• Check the connection between the
CONNECTOR and DVDM Assys (29-pin FFC).
Yes
Can any
operation be
stopped?
No
Yes
Yes
D
Is IC1851
damaged?
No
Check
that the voltage
at V+3D is
+3.3 V.
Refer to Addendum No. 4.
No
Are the pins bridged at IC1301
or IC1401 or IC1501?
Yes
[V+6R5V system]
Check that the voltage
at C1854(+) is
+11 V.
E
No
Is IC1852
damaged?
No
Yes
Yes
Replace IC1852.
• Check the connections at D1852 and CN1801.
• Check the connection between the AJKB
and CONNECTOR Assys (15-pin FFC).
• Check the connection between the
CONNECTOR and DVDM Assys (29-pin FFC).
Check
that the voltage
at V+6R5V is
+6.5 V.
A
F
64
No
Are the pins bridged at IC101?
PD-D6-J
1
2
3
4
5
6
7
8
A
A
Signals available in the SACD
format are only analog outputs.
Are all
types of audio
signals output?
No
Only
analog audio
signals are
output.
[V-12V system]
Check that the voltage
at C1804(-) is
-17 V.
No
Yes
Yes
No
Check the connections at
D1803, D1804, and CN1801.
No
Replace D1805 and Q1801,
in that order.
Yes
• Check pin 225 at IC201.
• Check the connection between the DVDM
and CONNECTOR Assys (29-pin FFC).
• Check the connection between the
CONNECTOR and AJKB Assys
(15-pin FFC).
Check
that the voltage
at C1804 is
-10.8 V.
B
Yes
Yes
Normal operation
Replace D1808 and Q1804,
in that order.
Only
optical or COAX
audio signals are
output.
Yes
Check if the pins are short-circuited
at IC1101, IC1201, or IC1102.
Yes
• Check the input and output signals
to/from IC1701.
• Check V+3D.
C
D
E
F
65
PD-D6-J
5
6
7
8
1
No.
1
A
2
Symptoms
3
Diagnosis Contents
Possible Defective Points
The power is not turned on. Are wires of output connector (POWER SUPPLY Unit) and CN901
(DVDM Assy) disconnected or damaged ?
Check that the following voltage is output :
+ side of C739 : 3.3V
2
Addendum No.1
Connector / cable
DVDM Assy
3.3V Regulator IC (IC341)
An opening screen is not
Are the signals output from IC201-pin 98 (MDATA) and pin 99 (SCLK)
displayed on the monitor
on the DVDM Assy ? (in the range of 0-3V)
(The FL display lights. The
mechanism does not work.)
Are the signals input into IC2101-pin 50 (MDATA) and pin 51 (SCLK)
on the LCD Assy ? (in the range of 0-3V)
B
4
DVDM Assy
DVD IC (IC201)
LCD Assy
UCOM (IC2101)
Check that the following voltage are output :
IC751-pin 1 on the DVDM Assy : 5V
DVDM Assy
5V Regulator IC (IC751)
Is a resonator (X202: 27MHz) on the DVDM Assy oscillating ?
DVDM Assy
Crystal resonator (X202)
• Is a signal input into IC203-pin26 (PCE#) on the DVDM Assy ?
(Is a signal "H" for 80 mS and then "L" after the power is turned
on ?)
→ Communication with flash ROM.
• Are the signals input into IC202-pin 16 (DWE#), pin 19 (DCS#)
and pin 38 (SDCLK) on the DVDM Assy ?
(Is a signal fluctuating ?)
→ Communication with SDRAM
DVDM Assy
DVD IC (IC201)
Flash ROM (IC203)
SDRAM (IC202)
C
Is a signal output from IC203-pin 28 (PRD#) on the DVDM Assy?
DVDM Assy
(Is a signal fluctuating for several hundred mS after the power is turned Flash ROM (IC203)
on ?)
Is a signal input into IC2101-pin 67 (DVD ACK) on the LCD Assy ?
(Is a signal fluctuating ?)
→ Communication with FL Control IC
DVDM Assy
DVD IC (IC201)
LCD Assy
UCOM (IC2101)
Is a signal output from IC2101-pin 30 (XREADY) on the LCD Assy ?
(Is a signal fluctuating in the range of 0-5V ?)
LCD Assy
UCOM (IC2101)
DVDM Assy
Are the signals output from IC2101-pin 49 (SDATA) on the LCD Assy ? DVD IC (IC201)
(in the range of 0-5V)
LCD Assy
UCOM (IC2101)
D
Are the signals of IC204-pin 5(SDA) and pin 6(SCL) on the DVDM Assy DVDM Assy
fluctuating for one or two seconds after the power is turned ?
EEPROM (IC204)
E
3
A tray cannot be opened.
(An opening screen is
displayed on the monitor)
Does the voltage of CN104-pin 3 and pin 5 on the DVDM Assy change
normally ?
Pin 3 (SW2(TRIN)): Tray is fully closed: "L"
Pin 5 (SW1(TROUT)): Tray is fully opened: "L"
Is the signal input into IC101-pin 11 (TROPEN) on the DVDM Assy ?
At open: 3.3V, At close: 0V
Are the signals output from IC101-pin 1 and pin 2 (CN103-pin 1 and
pin 2) on the DVDM Assy ?
Pin 2: Approx. 6V during opening tray approx. 0V during closing tray.
Pin 1: Approx. 0V during opening tray approx. 6V during closing tray.
LOAB Assy
Tray SW (S101)
DVDM Assy
DVD IC (IC201)
DVDM Assy
FTS Driver IC (IC101)
Are wires of CN104 and CN103 on the DVDM Assy disconnected or
damaged ?
Connector / cable
Does the voltage of CN102-pin 1 on the DVDM Assy change to 0V by
pressing the Inside switch.
Inside switch
F
66
PD-D6-J
1
2
3
4
5
No.
Symptoms
Addendum No.2
4
Playback impossible
(no focusing)
Addendum No.3
5
Playback impossible
(Spindle does not turn)
Addendum No.4
6
6
Playback impossible
(Playback stops)
7
Diagnosis Contents
8
Possible Defective Points
Are the signals output from IC101-pin 3 (FOCS_DRV) and pin 4
(FOCS_RTN) on the DVDM Assy ?
Does 650-nm LD emit light ?
Does a pickup lens move up / down ?
Does an actuator spring bend ?
Are plastic parts damaged ? Or is a shaft detached ?
Is the turntable detached or tilted ?
Is flexible cable of CN101 on the DVDM Assy disconnected or
damaged ?
Is signal output from IC201-pin 42 (FOSO) on the DVDM Assy ?
(Device control of about 1.4 V is output usually. It is fluctuated by about
± 250 mV with focus up / down.)
Are the signals output from IC101-pin 30 (W), pin 33 (V) and pin 35 (U)
on the DVDM Assy ?
Is pin 26 (STBY) fixed LOW ? (pin 26 is High at playback: 3V)
Is there any part detached from the spindle motor ?
Or Is there any foreign object lodged in it ?
Are wires of CN102 on the DVDM Assy disconnected or damaged ?
DVDM Assy
FTS Driver IC (IC101)
A
Pickup
Mechanism section (motor)
Flexible cable / connector
DVDM Assy
DVD IC (IC201)
DVDM Assy
FTS Driver IC (IC101)
B
Mechanism section
(Spindle motor)
Flexible cable / connector
DVDM Assy
Is signal output from IC201-pin 37 (DMSO) on the DVDM Assy ?
DVD IC (IC201)
Does 650-nm LD deteriorate ?
650-nm LD deteriorated.
If the voltage at each both ends of R322 and R325 on the DVDM Assy (When playback of a DVD is
is 0.4 V or more, the 650-nm LD is definitely deteriorated.
impossible)
Does 780-nm LD deteriorate ?
780-nm LD deteriorated.
If the voltage at each both ends of R321 and R326 on the DVDM Assy (When playback of a CD is
is 0.4 V or more, the 780-nm LD is definitely deteriorated.
impossible)
DVDM Assy
Is there abnormality in FG waveform ? (IC201-pin 47)
FG output : FTS Driver IC (IC101)
Are there scratches or dirt on the disc ?
C
Disc
D
E
F
67
PD-D6-J
5
6
7
8
1
2
3
4
7.1.4 SEQUENCE AFTER POWER ON/OFF
Normal POWER-ON sequences
A
Set time for the current step
Elapsed time
Details on control
POWER ON start, Various initial settings 1
0 msec
All keys are masked.
XSYSMUTE ON
Various initial settings 2
+ 60 msec
60 msec
+ 240 msec
300 msec
+ 60 msec
360 msec
+ 1020 msec
1380 msec
Various initial settings 4
+ 390 msec
1770 msec
Various initial settings 5
+ 120 msec
1890 msec
Various initial settings 6
+ 3120 msec
5010 msec
Various initial settings 7
+ 30 msec
5040 msec
POWER ON completed
SYSPOW ON
When the power is turned on, the HELLO display is requested (3.5 sec).
Various initial settings 3
RESET L ⇒ H
Various initial settings 4
B
C
Control of the LCD driver starts.
Data transmission
Bus communication starts.
Masking of all keys is canceled.
Temporary data transmission
Normal POWER-OFF sequences
Set time for the current step
Elapsed time
0 msec
Details on control
POWER OFF start, Various settings 1
The mask flags for all keys are set.
Various settings 2
D
E
+ 30 msec
30 msec
(Note 1)
Whether the DVD is turned off or not is checked.
Bus communication is terminated.
+ 120 msec
150 msec
Various settings 3
+ 330 msec
480 msec
Various settings 4
+ 1320 msec
1800 msec
Various settings 4
+ 90 msec
1890 msec
Various settings 5
+ 240 msec
2130 msec
Processing for the ports required when the power is turned off
+ 30 msec
2160 msec
POWER OFF completed
All the indications on the LCD are deleted.
(passes every loop in the POWER OFF)
Note 1: In this step, the unit wait for the DVD module to turn the power off. If the DVD module takes a longer time to turn itself off,
the elapsed time will become longer, by just that much.
F
68
PD-D6-J
1
2
3
4
5
6
7
8
Display Only POWER-ON sequences
Set time for the current step
Elapsed time
A
Details on control
Display only POWER ON start, Various initial settings 1
All keys are masked.
The normal operation keys are masked.
POWER MUTE ON
SYSTEM POWER1 ON (Pin 91: H)
0 msec
+ 60 msec
Various initial settings 2
60 msec
Various initial settings 3
Switched 5 V ON completed (power supply is stabilized)
Masking of the normal operation keys is canceled.
SYSTEM POWER2 ON (Pin 92: H)
+ 240 msec
300 msec
+ 60 msec
360 msec
Various initial settings 4
+ 330 msec
690 msec
Display Only POWER ON completed
B
Power-on of the LCD driver starts.
C
Display-only POWER-OFF sequences
Set time for the current step
Elapsed time
Details on control
Display-only POWER OFF start, Various settings 1
• The mask flags for all the keys are set.
• The mask flags for the normal operation keys are set.
• Muting the power system (SYSTEM MUTE REQUEST)
• Power-off of the LCD driver starts.
0 msec
+ 4120 msec
4120 msec
Various settings 2
+ 120 msec
4240 msec
Various settings 3
D
Various settings 4
+ 760 msec
+ 240 msec
• The mask flags for all keys are set.
• Muting of the power system is canceled.
• Other than in an emergency power-off, the unit awaits for a while.
• SYSTEM POWER2 OFF (Pin 92: H)
5000 msec
E
Display-only POWER OFF completed
5240 msec
• SYSTEM POWER1 OFF (Pin 91: H)
F
69
PD-D6-J
5
6
7
8
F
1
70
2
Other output port
Others
ok LCD reset
ok LCD setting
LCD control
ok SYSTEM BUS
(DVD)
XDVDRESET
DVD ON/OFF
DVD control
ok SYSPOW
(pin 41)
ok XSYSMUTE
(pin 38)
E
600
900
1200
Subsequently, H or L is output, as appropriate.
(Port setting)
300
PON4
1380 msec
1500
PON6
1800
PON5
2100
2400
C
SYSTEM
PON1
60 msec
PON2
D
KEY input
0 msec
PON2
2700
4800
PON7
B
1 Standby → On
POWER-ON timing waveform
5100
PON8
1
2
3
3
4
A
PD-D6-J
4
5
6
XDimmer (pin 70)
(DIMMER)
Others
LCD setting
(pins 26,27,28)
LCD reset (pin 36)
(XLCDRST)
LCD control
DVD ON/OFF (pin 1)
(DVD ON/OFF)
XDVDRESET (pin 93)
(XDVDRST)
SYSTEM BUS (DVD)
(pins 30,49,50,51,67)
DVD control
SYSMUTE (pin 38)
SYSPOW (pin 41)
SYSTEM
POFFG0
0 msec
POFF1
30 msec
2 On → Standby
300
600
POFF2 POFF3
POWER-OFF timing waveform
900
1200
1500
1800
POFF4
2100
POFF5
2400
POFF6
2700
3000
3300
3600
4500
4800
5
6
7
7
8
A
B
C
D
E
F
PD-D6-J
8
71
1
2
3
4
7.1.5 DISASSEMBLY
A
Note 1: Do NOT look directly into the pickup lens. The laser beam may cause eye injury.
Note 2: Even if the unit shown in the photos and illustrations in this manual may differ from your product, the procedures
described here are common.
Note 3: For performing the diagnosis the DVDM ASSY side B, the following jigs for service is required:
• Cable for service (GGD1425)
Diagnosis of PCB's
1 Bonnet , Tray Panel
1
How to open the Tray when the power cannot be on
Remove the Bonnet by removing the ten screws.
B
Insert a Screwdriver (small) into the Slit located at the bottom of
the unit, and slide the projection of the Drive Cam in the 05
LOADER ASSY in the direction of the arrow, as indicated in the
photo. If the Tray pops out a little, fully pull it out by hand.
Bonnet
1
1
1
1
1
1
1
1
Slit
1
Screwdriver (small)
1
C
D
2
3
4
5
6
Press the STANDBY/ON button to turn on the power.
7
8
Press the STANDBY/ON button to turn off the power.
Tray open
Press the 0 OPEN/CLOSE button to open the Tray.
Remove the Tray Panel.
Set the Test Disc.
Press the 0 OPEN/CLOSE button to close the Tray.
(Test Disc is clamped.)
Pull out the Power cord.
Test disc
5
2 7
4
Screwdriver (small)
Projection
E
3
6
Tray
3 6
Tray Panel
Drive cam
05 LOADER ASSY
Bottom view
F
72
PD-D6-J
1
2
3
4
5
6
7
8
2 DVDM ASSY
1
Remove the two screws which secure two Grounding wires
in place.
2
Remove the four screws.
4
A
Extend the two Grounding wires which were removed in
procedures 1 and connect them to Chassis for grounding.
Grounding wires
05 LOADER ASSY
Grounding wires
2
2
B
1
1
2
2
Chassis
Top View
C
5
3
Raise the 05 LOADER ASSY.
Slightly lift the 05 LOADER ASSY and displace it slightly
backward.
D
3
5
E
05 LOADER ASSY
Diagnosis
Note:
Service cable 5P (GGD1425) is required when
diagnosing the DVDM ASSY side B.
F
73
PD-D6-J
5
6
7
8
1
2
3
4
A
E
D
PLED ASSY
LCD ASSY
F
MNSW ASSY
J
G
B
TRANS ASSY
KEY ASSY
C
H
I
CONECTOR ASSY
B
PRIMARY ASSY
DVDM ASSY
C
AJKB ASSY
D
E
F
74
PD-D6-J
1
2
3
4
5
6
7
8
Removing the Traverse Mechanism Assy-S and 05SD Pickup Assy-S
A
1 05 LOADER Assy
1
2
Short-circuit point by soldering.
Disconnect the three flexible cables.
Note: After replacement, connect the flexible
cable for pickup, then remove the
soldered joint (open).
DVDM Assy
05SD Pickup Assy-S
B
2
1
2
2
Bottom view
Rear view
05 LOADER Assy
C
2 Bridge 04, Tray
1
2
3
Remove the one screw.
3
Remove the bridge 04.
-2
Hook
Pull out the tray, then remove it by pressing the
hook.
Bridge 04
D
1
1
2
Note when reinserting the tray
E
When reinserting the tray, first align the triangle
printed on the loading base and the pin of the drive
cam, then insert the tray.
Drive cam
Pin
3
-2
Tray
Front side
Loading base
F
Triangle
75
PD-D6-J
5
6
7
8
1
2
3
4
3 Traverse Mechanism Assy-S
A
1
Flexible cable
for the spindle motor
Dislodge the two flexible cables from their factory
placement.
Front Side
1
B
1
C
Flexible cable for the pickup
Bottom view
D
2
3
Unhook the four hooks.
Traverse Mechanism Assy-S
Remove the Traverse Mechanism Assy-S
2
×2
3
E
2
×2
F
76
PD-D6-J
1
2
3
4
5
6
7
8
4 05SD Pickup Assy-S
A
Note: The 05SD Pickup Assy can be removed
without removing the TTraverse Mechanism
Assy-S.(shown as Step π.)
05SD Pickup Assy-S
1
Front Side
Disconnect the flexible cable for the pickup.
B
1
C
Flexible cable for the pickup
Bottom view
D
2
3
Remove the two adjustment screws.
Adjustment screw
(skew screw VK1)
Remove the 05SD Pickup Assy.
2
2
Adjustment screw
(skew screw VK1)
05SD Pickup Assy-S
3
E
Note: Be careful not to lose the adjustment spring
(skew spring VK1).
Adjustment screw
(skew screw VK1)
Adjustment spring
(skew spring VK1)
F
77
PD-D6-J
5
6
7
8
1
4
A
2
3
4
Remove the one screw.
05SD Pickup Assy
Note: The screw is secured with the silicone
adhesive.
Make sure to apply the silicone adhesive after
reattaching the screw.
Joint VK1B
B
Joint spring VK1
4
Silicone Adhesive
GEM1037
C
Arrangement of the flexible cable for the spindle motor
: Conductive surface
Hook
Front Side
D
E
Hook
F
Bottom view
78
PD-D6-J
1
2
3
4
5
6
7
8
Arrangement of the flexible cable for the pickup
A
: Conductive surface
Note:
Be sure to move the 05SD Pickup Assy to the innermost perimeter.
1
Fold the flexible cable for the pickup with the backing outward
in the illustration below.
4
5
Hook the part folded in Step 1 to the hook.
Pass the flexible cable through the hook.
Reference line
Reference line
Hook
1
B
5
4
Backing
76 mm
Hook
C
2
Attach the flexible cable for the pickup to the connector.
6
7
Fold the flexible cable along the hook.
Pass the flexible cable through the hook.
Hook
2
7
Backing
6
Front Side
D
Bottom View
Hook
3
Pass the flexible cable through the hook.
E
Hook
Hook
3
Make sure that the cable is loose
F
79
PD-D6-J
5
6
7
8
1
2
3
4
7.1.6 PANEL ADJUSTING
How to adjust the AL Panel (when replacing the AL Panel L)
A
Set the top and bottom edges of the AL Panel L even with R and tighten the screws.
Adjust this gap to zero (0).
B
AL Panel L
AL Panel R
C
OK
NG
D
Screw for securing the AL Panel L
(Tighten the screw while adjusting the gap.)
E
Rear face of the Panel ASSY
F
80
PD-D6-J
1
2
3
4
5
6
7
8
7.2 PARTS
7.2.1 IC
A
• The information shown in the list is basic information and may not correspond exactly to that shown in the schematic diagrams.
• List of IC
PDC148A, MT1389EE/B2-L
PDC148A (LCD ASSY : IC2101)
• System Control Microcomputer
Pin Function
No.
Mark
Pin Name
I/O
Pin Function
B
1
PA3/WR#
NC
O
2
PA4/RD#
NC
O
3
PA5/RS
NC
O
4
P70 / INT0 / T0LCP / AN8
ACPULSE
I
AC PULSE input(Interruption)
5
P71 / INT1 / T0HCP / AN9
LED2
O
Power-on indicator
6
P72 / INT2 / T0IN
LED1
O
Pure audio indicator
7
P73 / INT3 / T0IN
REMOCON
I
REMOCON signal input(Interruption)
8
RES#
XRESET
I
µ -com reset input
9
XT1 / AN10
XT1
−
32.768kHz sub clock connection (0.1W correspondence)
10
XT2 / AN11
XT2
−
32.768kHz sub clock connection (0.1W correspondence)
11
VSS1
VSS1
−
VSS1
C
12
CF1
CF1
−
10MHz crystal oscillator
13
CF2
CF2
−
10MHz crystal oscillator
14
VDD1
VDD1
−
VDD1
15
P80 / AN0
SIMUKE
I
Destination distinction input
16
P81 / AN1
NC
I
17
P82 / AN2
VDET
I
DVD3.3V detection input
18
P83 / AN3
KEY1
I
Key Input
19
P84 / AN4
NC
I
Key Input
20
P85 / AN5
NC
I
21
P86 / AN6
NC
I
22
P87 / AN7
NC
I
23
P10 / SO0
XDFDT
O
AQE serial control DATA
24
P11 / SI0 / SB0
XDFCS
O
AQE serial control CS
25
P12 / SCK0
XDFCLK
O
AQE serial control CLK
26
P13 / SO1
LCDDAT
O
Data for LCD driver
27
P14 / SI1 / SB1
LCDCS
O
Chip enable for LCD driver
28
P15 / SCK1
LCDCLK
O
Clock for LCD driver
29
P16 / T1PWML
XDFRST
O
AQE reset
30
P17 / T1PWMH/BUZ
XREADY
O
Chip select for system bus(MTK XREADY)
31
PE0
O
PCM/DSD data select
32
PE1
XPCM/DSD
NC
33
PE2
NC
O
34
PE3
NC
O
35
PE4
NC
O
36
PE5
XDACRST
O
37
PE6
NC
O
D
E
O
DAC reset
38
PE7
XSYSMUTE
O
Control mute of system
39
VSS4
VSS4
−
VSS4
40
VDD4
VDD4
−
VDD4
F
81
PD-D6-J
5
6
7
8
1
No.
A
B
C
D
E
2
Mark
Pin Name
3
I/O
4
Pin Function
41
PF0
SYSPOW
O
Control power supply of system
42
PF1
NC
O
43
PF2
STEST
I
Set TESTMODE for Service
44
PF3
UTEST
I
Set UNITCHECK for checker
45
PF4
NC
O
46
PF5
NC
O
47
PF6
NC
O
48
PF7
NC
O
49
SI2P0/SO2
SDATA
O
System bus data output (AMP side output) for DVD
50
SI2P1/SI2/SB2
MDATA
I
System bus data input (AMP side input) for DVD
51
SI2P2/SCK2
SCLK
I
System bus clock input
52
SI2P3/SCK20
XDVDRST
O
RESET to DVD MODULE
53
PWM1
NC
54
PWM0
NC
55
VDD2
VDD2
−
VDD2
56
VSS2
VSS2
−
VSS2
57
P00
NC
O
58
P01
NC
O
59
P02
NC
O
60
P03
NC
O
61
P04
NC
O
62
P05
NC
O
63
P06
NC
O
64
P07
NC
O
65
P20/INT4/T1IN
NC
O
66
P21/INT4/T1IN
NC
I
67
P22/INT4/T1IN
DVDACK
I
68
P23/INT4/T1IN
NC
I
69
P24/INT5/T1IN
NC
O
70
P25/INT5/T1IN
NC
O
71
P26/INT5/T1IN
NC
O
72
P27/INT5/T1IN
NC
O
73
P30
NC
O
74
P31
TRIN
I
LOADING SW2 INPUT
75
P32
TROUT
I
LOADING SW1 INPUT
76
P33
LOADGAIN
O
Loading gain select
77
P34
NC
O
78
P35
NC
O
79
P36
NC
O
80
PB7/D7
DVDM ON/OFF
O
Ackknowlegement from DVD MODULE(Interruption)
Control power supply for DVD module
F
82
PD-D6-J
1
2
3
4
5
No.
6
Mark
Pin Name
7
I/O
8
Pin Function
81
PB6/D6
NC
O
82
PB5/D5
XLCDRST
O
83
PB4/D4
NC
O
84
PB3/D3
NC
O
85
PB2/D2
LCDRS
O
86
PB1/D1
NC
O
87
PB0/D0
NC
O
88
VSS3
VSS3
−
VSS3
89
VDD3
VDD3
−
VDD3
90
PC7/A7
P_SPDIF_POW
O
SPDIF output on/off control
91
PC6/A6
NC
O
92
PC5/A5
SYSPOW2
O
0.1W correspondence of System Power Control
93
PC4/A4
MSDCT
I
Mechanical power SW detect
94
PC3/A3
DIMMER
O
Dimmer control
95
PC2/A2
BLON
O
LCD Backlight ON
96
PC1/A1
LED3
O
Standby indicator
97
PC0/A0
NC
O
Reset for LCD driver (standby)
LCD register select signal
98
PA0/CS2#
FLASHE/D
−
for FLASH writing
99
PA1/CS1#
FLASHDO
−
for FLASH writing
FLASHCLK
−
for FLASH writing
100 PA2/CS0#
A
B
C
D
E
F
83
PD-D6-J
5
6
7
8
APLLVDD3
IOWR#
A16
HIGHA7
HIGHA6
HIGHA5
HIGHA4
HIGHA3
DVDD3
HIGHA2
HIGHA1
IOA20
IOCS#
IOA1
IOOE#
DVDD3
AD0
AD1
AD2
AD3
DVSS
AD4
AD5
AD6
IOA21 / V_ADIN0
ALE
AD7
A17
IOA0
DVSS
UWR#
URD#
DVDD18
UP1_2
UP1_3
UP1_4
UP1_5
UP1_6
UP1_7
UP3_0
UP3_1
UP3_4
UP3_5
DVDD3
ICE
PRST#
IR
INT0#
DQM0
DQS0
RD7
DVSS
RD6
RD5
DVSS
RD4
RD3
DVDD18
RD2
RD1
RD0
RD15
DVDD3
RD14
65
66
67
68
69
70
71
72
73
74
75
76
77
78
79
80
81
82
83
84
85
86
87
88
89
90
91
92
93
94
95
96
97
98
99
100
101
102
103
104
105
106
107
108
109
110
111
112
113
114
115
116
117
118
119
120
121
122
123
124
125
126
127
128
256
255
254
253
252
251
250
249
248
247
246
245
244
243
242
241
240
239
238
237
236
235
234
233
232
231
230
229
228
227
226
225
224
223
222
221
220
219
218
217
216
215
214
213
212
211
210
209
208
207
206
205
204
203
202
201
200
199
198
197
196
195
194
193
B
C
D
E
AVDD3
IREF
RFGC
OSN
OSP
CEQN
CEQP
RFGND
CRTPLP
HRFZC
RFRPAC
RFRPDC
RFVDD3
S_VREFN
S_VREFP
ADCVSS
S_VCM
ADCVDD3
LPFOP
LPFIN
LPFIP
LPFON
PLLVDD3
IDACEXLP
PLLVSS
JITFN
JITFO
XTALI
XTALO
RFVDD18
RFGND18
SPDIF
MC_DATA
DVSS
ASDATA4
DVDD18
ASDATA3
ASDATA2
ASDATA1
ASDATA0
DVSS
ACLK
ABCK
ALRCK
DVDD3
SPBCK
SPLRCK
SPDATA
SPMCLK
HSYN / V_ADIN2
YUV7
VSYN / V_ADIN1
DVDD3
YUV6/R
YUV5/B
DACVSSA
YUV4/G
DACVDDA
YUV3/CVBS
DACVSSB
YUV2/C
DACVDDB
YUV1/Y
DACVSSC
1
A
AGND
DVDA
DVDB
DVDC
DVDD
DVDRFIP
DVDRFIN
MA
MB
MC
MD
SA
SB
SC
SD
CDFON
CDFOP
TNI
TPI
MDI1
MDI2
LDO2
LDO1
SVDD3
CSO / RFOP
RFLVL / RFON
SGND
V2REFO
V20
VREFO
FEO
TEO
TEZISLV
OP_OUT
OP_INN
OP_INP
DMO
FMO
TROPENPWM
PWMOUT1 / V_ADIN9
TRO
FOO
USB_VSS
USBP
USBM
USB_VDD3
FG / V_ADIN8
TDI / V_ADIN4
TMS / V_ADIN5
TCK / V_ADIN6
TDO / V_ADIN7
DVDD18
IOA2
IOA3
IOA4
IOA5
IOA6
IOA7
HIGHA0
IOA18
IOA19
DVSS
APLLCAP
APLLVSS
1
2
84
2
3
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
3
4
MT1389EE/B2-L (DVDM ASSY : IC201)
• DVD IC
Pin Arrangement
192
191
190
189
188
187
186
185
184
183
182
181
180
179
178
177
176
175
174
173
172
171
170
169
168
167
166
165
164
163
162
161
160
159
158
157
156
155
154
153
152
151
150
149
148
147
146
145
144
143
142
141
140
139
138
137
136
135
134
133
132
131
130
129
F
PD-D6-J
4
YUV0/CIN
FS
VREF
DACVDDC
RD16
RD17
RD18
RD19
RD20
RD21
DVDD3
RD22
RD23
DQM2
DQM3
RD24
RD25
DVSS
RD26
DVDD18
RD27
RD28
RD29
RD30
RD31
DVDD3
RA4
RA5
RA6
DVSS
RA7
DVSS
RA8
RA9
RA11
CKE
RCLK
DVDD3
RCLKB
RVREF / V_ADIN 3
DVDD18
RA3
RA2
RA1
DVSS
RA0
RA10
BA1
DVSS
BA0
RCS#
DVDD3
RAS#
CAS#
RWE#
DQM1
DQS1
RD8
DVSS
RD9
RD10
RD11
RD12
RD13
5
6
7
8
Block Diagram
A
DVD
PUH
Module
RF
Amplifier
Debug
Port
Servo I/O
B
Servo
Processor
Motor
Drive
Spindle
Control
MPEG-1/2
MPEG-4
JPEG
Video Decoder
Flash ROM
Memory
Controller
Audio
DSP
C
SACD
Processor
DRAM
USB
Controller
PCM / DSD
System
Parser
Audio
Output
CPPM/CPRM
DRM
System
CPU
GPIO
Audio
DAC
SPDIF
D
30-bit
RISC
IR/VFD
E
F
85
PD-D6-J
5
6
7
8
1
2
3
4
Pin Function
RF Interface (28)
A
No.
B
C
Name
Alt.
I/O
Function
226 RFGND18
Ground
Analog ground
227 RFVDD18
Power
Analog power 1.8V
250 CEQP
Analog output
EQ offset loop capacitance
251 CEQN
Analog output
EQ offset loop capacitance
252 OSP
Analog output
RF Offset cancellation capacitor connecting
253 OSN
Analog output
RF Offset cancellation capacitor connecting
254 RFGC
Analog output
RF AGC loop capacitor connecting for DVD-ROM
255 IREF
Analog Input
Current reference input
256 AVDD3
Power
Analog power 3.3V
1 AGND
Ground
Analog ground
2 DVDA
Analog Input
AC coupled input path A
3 DVDB
Analog Input
AC coupled input path B
4 DVDC
Analog Input
AC coupled input path C
5 DVDD
Analog Input
AC coupled input path D
6 DVDRFIP
Analog Input
AC coupled DVD RF signal input RFIP
7 DVDRFIN
Analog Input
AC coupled DVD RF signal input RFIN
8 MA
Analog Input
DC coupled main-beam RF signal input A
9 MB
Analog Input
DC coupled main-beam RF signal input B
10 MC
Analog Input
DC coupled main-beam RF signal input C
11 MD
Analog Input
DC coupled main-beam RF signal input D
12 SA
Analog Input
DC coupled sub-beam RF signal input A
13 SB
Analog Input
DC coupled sub-beam RF signal input B
14 SC
Analog Input
DC coupled sub-beam RF signal input C
15 SD
Analog Input
DC coupled sub-beam RF signal input D
16 CDFON
Analog Input
CD focusing error negative input
17 CDFOP
Analog Input
CD focusing error positive input
18 TNI
Analog Input
3 beam satellite PD signal negative input
19 TPI
Analog Input
3 beam satellite PD signal positive input
D
ALPC (4)
No.
Name
Alt.
I/O
Function
20 MDI1
Analog Input
Laser power monitor input
21 MDI2
Analog Input
Laser power monitor input
22 LDO2
Analog Output
Laser driver output
23 LDO1
Analog Output
Laser driver output
ADC for SACD (5)
No.
E
Name
Alt.
I/O
Function
239 ADCVDD3
Power
Analog 3.3V Power for ADC
240 S_VCM
Analog Inout
SACD- Common mode reference
241 ADCVSS
Ground
Analog ground for ADC
242 S_VREFP
Analog Inout
SACD- TOP Reference
243 S_VREFN
Analog Inout
SACD- Bottom Reference
Reference Voltage (3)
No.
F
Name
Alt.
I/O
Function
28 V2REFO
Analog output
Reference voltage 2.8V
29 V20
Analog output
Reference voltage 2.0V
30 VREFO
Analog output
Reference voltage 1.4V
86
PD-D6-J
1
2
3
4
5
6
7
8
Analog Monitor Output (7)
No.
Name
Alt.
24 SVDD3
I/O
Function
Power
Analog power 3.3V
25 CSO
RFOP
Analog output
NC
26 RFLVL
RFON
Analog output
NC
27 SGND
Ground
Analog ground
31 FEO
Analog output
Focus error monitor output
32 TEO
Analog output
Tracking error monitor output
33 TEZISLV
Analog output
TE Slicing Level
A
Analog Servo Interface (6)
No.
Name
Alt.
I/O
Function
244 RFVDD3
Power
Analog Power
245 RFRPDC
Analog output
RF ripple detect output
246 RFRPAC
Analog Input
RF ripple detect input(through AC-coupling)
247 HRFZC
Analog Input
High frequency RF ripple zero crossing
248 CRTPLP
Analog output
Defect level filter capacitor connecting
249 RFGND
Ground
Analog Ground
B
RF Data PLL Interface (9)
No.
Name
Alt.
I/O
Function
230 JITFO
Analog output
The output terminal of RF jitter meter.
231 JITFN
Analog Input
The input terminal of RF jitter meter.
232 PLLVSS
Ground
Ground pin for data PLL and related analog circuitry.
233 IDACEXLP
Analog output
Data PLL DAC Low-pass filter
234 PLLVDD3
Power
Power pin for data PLL and related analog circuitry.
235 LPFON
Analog Output
The negative output of loop filter amplifier
236 LPFIP
Analog Input
The positive input terminal of loop filter amplifier.
237 LPFIN
Analog Input
The negative input terminal of loop filter amplifier.
238 LPFOP
Analog Output
The positive output of loop filter amplifier
C
Motor and Actuator Driver Interface (10)
No.
Name
Alt.
I/O
Function
34 OP_OUT
Analog output
NC
35 OP_INN
Analog input
NC
36 OP_INP
Analog input
NC
37 DMO
Analog Output
Spindle motor control output. PWM output.
38 FMO
Analog Output
Sled motor control output. PWM output.
Analog Output
Tray open / close control output.
39 TROPENPWM
40 PWMOUT1
V_ADIN9
D
Analog Output
Sled motor control output
41 TRO
Analog Output
Tracking servo output. PDM output of tracking servo compensator.
42 FOO
Analog Output
Focus servo output. PDM output of focus servo compensator
47 FG (Digital pin)
LVTTL 3.3V Input,
Schmitt Input,
pull-up , with
Motor Hall sensor input
analog input path
for V_ADIN8
V_ADIN8
E
F
87
PD-D6-J
5
6
7
8
1
2
3
4
General Power / Ground (32)
No.
A
B
Name
Alt.
I/O
Function
52, 97, 122,
152, 173, 221
DVDD18
Power
1.8V power pin for internal digital circuitry
85, 116, 144,
163, 216
DVSS
Ground
1.8V Ground pin for internal digital circuitry
73, 80, 108,
127, 141, 155,
167, 182, 212
DVDD3
Power
3.3V power pin for internal digital circuitry
62, 94, 119,
134, 148, 161,
175, 223
DVSS
Ground
3.3V Ground pin for internal digital circuitry
204
DVDD3
Power
3.3V power pin Video DAC digital circuitry only
63
APLLCAP
Analog Inout
APLL External Capacitance connection
64
APLLVSS
Ground
Ground pin for audio clock circuitry
65
APLLVDD3
Power
3.3V Power pin for audio clock circuitry
Micro Controller and Flash Interface (48)
No.
C
D
E
Name
Alt.
I/O
Function
59 HIGHA0
Inout, 2-16MA, SR, PU
Flash address 8
75 HIGHA1
Inout, 2-16MA, SR, PU
Flash address 9
74 HIGHA2
Inout, 2-16MA, SR, PU
Flash address 10
72 HIGHA3
Inout, 2-16MA, SR, PU
Flash address 11
71 HIGHA4
Inout, 2-16MA, SR, PU
Flash address 12
70 HIGHA5
Inout, 2-16MA, SR, PU
Flash address 13
69 HIGHA6
Inout, 2-16MA, SR, PU
Flash address 14
68 HIGHA7
Inout, 2-16MA, SR, PU
Flash address 15
91 AD7
Inout, 2-16MA, SR
Flash data 7
88 AD6
Inout, 2-16MA, SR
Flash data 6
87 AD5
Inout, 2-16MA, SR
Flash data 5
86 AD4
Inout, 2-16MA, SR
Flash data 4
84 AD3
Inout, 2-16MA, SR
Flash data 3
83 AD2
Inout, 2-16MA, SR
Flash data 2
82 AD1
Inout, 2-16MA, SR
Flash data 1
81 AD0
Inout, 2-16MA, SR
Flash data 0
93 IOA0
Inout, 2-16MA, SR, PU
Flash address 0 / IO
78 IOA1
Inout, 2-16MA, SR, PU
Flash address 1 / IO
53 IOA2
Inout, 2-16MA, SR, PU
Flash address 2 / IO
54 IOA3
Inout, 2-16MA, SR, PU
Flash address 3 / IO
55 IOA4
Inout, 2-16MA, SR, PU
Flash address 4 / IO
56 IOA5
Inout, 2-16MA, SR, PU
Flash address 5 / IO
57 IOA6
Inout, 2-16MA, SR, PU
Flash address 6 / IO
58 IOA7
Inout, 2-16MA, SR, PU
Flash address 7 / IO
67 A16
Output, 2-16MA, SR
Flash address 16
92 A17
Output, 2-16MA, SR
Flash address 17
60 IOA18
Inout, 2-16MA, SR, SMT
Flash address 18 / IO
61 IOA19
Inout, 2-16MA, SR, SMT
Flash address 19 / IO
76 IOA20
Inout, 2-16MA, SR, SMT
Flash address 20 / IO
89 IOA21
Inout, 2-16MA,
SR, SMT
IO
V_ADIN0
F
88
PD-D6-J
1
2
3
4
5
No.
6
Name
Alt.
7
I/O
8
Function
90 ALE
Inout, 2-16MA,
SR, PU, SMT
NC
79 IOOE#
Inout, 2-16MA, SR, SMT
Flash output enable, active low / IO
66 IOWR#
Inout, 2-16MA, SR, SMT
Flash write enable, active low / IO
77 IOCS#
Inout, 2-16MA,
SR, PU, SMT
Flash chip select, active low / IO
95 UWR#
Inout, 2-16MA,
SR, PU, SMT
NC
96 URD#
Inout, 2-16MA,
SR, PU, SMT
NC
98 UP1_2
Inout, 4MA, SR, PU, SMT
Microcontroller port 1-2
99 UP1_3
Inout, 4MA, SR, PU, SMT
Microcontroller port 1-3
100 UP1_4
Inout, 4MA, SR, PU, SMT
Microcontroller port 1-4
101 UP1_5
Inout, 4MA, SR, PU, SMT
Microcontroller port 1-5
A
B
102 UP1_6
SCL
Inout, 4MA, SR, PU, SMT
Microcontroller port 1-6
I2C clock pin
103 UP1_7
SDA
Inout, 4MA, SR, PU, SMT
Microcontroller port 1-7
I2C data pin
104 UP3_0
RXD
Inout, 4MA, SR, PU, SMT
Microcontroller port 3-0
8032 RS232 RXD
Inout, 4MA, SR, PU, SMT
Microcontroller port 3-1
8032 RS232 TXD
105 UP3_1
TXD
106 UP3_4
RXD
SCL
Inout, 4MA, SR, PU, SMT
Microcontroller port 3-4
Hardwired RD232 RXD
I2C clock pin
107 UP3_5
TXD
SDA
Inout, 4MA, SR, PU, SMT
Microcontroller port 3-5
Hardwired RD232 TXD
I2C data pin
111 IR
Input, SMT
IR control signal input
112 INT0#
Inout, 2-16MA,
SR, PU, SMT
Microcontroller external interrupt 0, active low
C
D
E
F
89
PD-D6-J
5
6
7
8
1
2
3
4
Audio Interface (14)
No.
A
Name
Alt.
I/O
SCLK0
Inout
GPIO
209 SPDATA
SDIN0
Inout
GPIO
210 SPLRCK
SDO0
Inout
GPIO
211 SPBCK
SDCS0
ASDATA5
Inout
GPIO
Inout
4MA, PD, SMT
213 ALRCK
B
214 ABCK
Output
4MA
Inout, 4MA
Fs64
215 ACLK
C
Function
208 SPMCLK
Audio left/right channel clock
Trap value in power-on reset:
1 : use external 373
0: use internal 373
Audio bit clock
Phase de-modulation
Audio DAC master clock
Audio serial data 0 (Front-Left/Front-Right)
DSD data left channel
Trap value in power-on reset :
1 : manufactory test mode
0 : normal operation
217 ASDATA0
Inout, 4MA,
PD SMT
218 ASDATA1
Inout, 4MA,
PD SMT
NC
219 ASDATA2
Inout, 4MA,
PD SMT
GPIO
Inout, 4MA,
PD SMT
220 ASDATA3
Audio serial data 3 (Center-back/ Center-left-back/Center-right-back, in 6.1 or
7.1 mode)
DSD data right channel
Trap value in power-on reset :
1 : manufactory test mode
0 : normal operation
While only 2 channels output:
GPIO
NC
222 ASDATA4
INT1#
Inout, 4MA,
PD SMT
224 MC_DATA
INT2#
Inout
NC
Output, 2-16MA,
SR : ON/OFF
SPDIF output
D
225 SPDIF
MISC (8)
No.
E
Name
Alt.
I/O
Function
110 PRST#
Input
PU, SMT
Power on reset input, active low
109 ICE
Input
PD, SMT
228 XTALO
Output
27M crystal out
229 XTALI
Input
27M crystal in
Microcontroller ICE mode enable
F
90
PD-D6-J
1
2
3
4
5
6
7
8
DRAM Interface (63)(sorted by position)
No.
Name
Alt.
I/O
Function
188 RD16
LLC_CLK
SMPTE_C[0]
Inout
Pull-Down
DRAM data 16
While using 16-bits wide DRAM:
Line Locked Clock input/output
Digital Video output C bit 0
GPIO
187 RD17
YUVIN0
SMPTE_C[1]
Inout
Pull-Down
DRAM data 17
While using 16-bits wide DRAM:
Video input data 0
Digital Video output C bit 1
GPIO
Inout
Pull-Down
DRAM data 18
While using 16-bits wide DRAM:
Video input data 1
Digital Video output C bit 2
GPIO
YUVIN1
SMPTE_C[2]
186 RD18
185 RD19
YUVIN2
SMPTE_C[3]
Inout
Pull-Down
DRAM data 19
While using 16-bits wide DRAM:
Video input data 2
Digital Video output C bit 3
GPIO
184 RD20
YUVIN3
SMPTE_C[4]
Inout
Pull-Down
DRAM data 20
While using 16-bits wide DRAM:
Video input data 3
Digital Video output C bit 4
GPIO
Inout
Pull-Down
DRAM data 21
While using 16-bits wide DRAM:
Video input data 4
Digital Video output C bit 5
GPIO
Inout
Pull-Down
DRAM data 22
While using 16-bits wide DRAM:
Video input data 5
Digital Video output C bit 6
GPIO
YUVIN4
SMPTE_C[5]
183 RD21
YUVIN5
SMPTE_C[6]
181 RD22
180 RD23
YUVIN6
SMPTE_C[7]
Inout
Pull-Down
DRAM data 23
While using 16-bits wide DRAM:
Video input data 6
Digital Video output C bit 7
GPIO
179 DQM2
YUVIN7
Inout
Pull-Up
Data Mask 2
While using 16-bits wide DRAM:
Video input data 7
GPIO
Inout
Pull-Up
Data Mask 3
While using 16-bits wide DRAM:
Microcontroller external interrupt 6
Digital Video output Clock
USB port CLK input (48MHz) part II
GPIO
Inout
Non-pull
DRAM data 24
While using 16-bits wide DRAM:
Serial interface port 1 data-in
MS Card BS pin part II
Digital Video output Y bit 0
GPIO
Inout
Non-pull
DRAM data 25
While using 16-bits wide DRAM:
Serial interface port 1 data-out
MS Card SDIO pin part II
Digital Video output Y bit 1
GPIO
INT6#
SMPTE_CLK
USB_CLK
178 DQM3
SDIN1
MS_BS
SMPTE_Y[0]
177 RD24
SDO1
MS_SDIO
SMPTE_Y[1]
176 RD25
A
B
C
D
E
F
91
PD-D6-J
5
6
7
8
1
No.
A
Name
2
Alt.
I/O
174 RD26
SDCS1
MSCLK
SMPTE_Y[2]
Inout
Non-pull
172 RD27
SCLK2
SDCLK
SMPTE_Y[3]
Inout
Non-pull
B
Inout
Non-pull
DRAM data 29
While using 16-bits wide DRAM:
Serial interface port 2 data-out
SD Card Data pin part II
Digital Video output Y bit 5
GPIO
Inout
Pull-Up
DRAM data 30
While using 16-bits wide DRAM:
Serial interface port 2 chip select
Digital Video output Y bit 6
GPIO
Inout
Pull-Up
DRAM data 31
While using 16-bits wide DRAM:
Microcontroller external interrupt 5
Audio serial data 5 part III : DSD data sub-woofer channel or Microphone
output
Digital Video output Y bit 7
GPIO
166 RA4
Inout
DRAM address 4
165 RA5
Inout
DRAM address 5
164 RA6
Inout
DRAM address 6
162 RA7
Inout
DRAM address 7
160 RA8
Inout
DRAM address 8
159 RA9
Inout
DRAM address 9
Inout
Pull-Down
DRAM address bit 11
While using DRAM size <=4MB:
GPIO
SDO2
SD_DAT
SMPTE_Y[5]
C
SDCS2
SMPTE_Y[6]
169 RD30
INT5#
ASDATA5
SMPTE_Y[7]
168 RD31
158 RA11
F
Function
DRAM data 26
While using 16-bits wide DRAM:
Serial interface port 1 chip select
Memory Stick Clock part II
Digital Video output Y bit 2
GPIO
DRAM data 27
While using 16-bits wide DRAM:
Serial interface port 2 clock pin
Security Disk Clock part II
Digital Video output Y bit 3
GPIO
Inout
Non-pull
SDIN2
SD_CMD
SMPTE_Y[4]
170 RD29
E
4
DRAM data 28
While using 16-bits wide DRAM:
Serial interface port 2 data-in
SD Card CMD pin part II
Digital Video output Y bit 4
GPIO
171 RD28
D
3
GPIO
157 CKE
output
DRAM clock enable
156 RCLK
Inout
DRAM clock
154 RCLKB
USB_CLK
Inout
DRAM clock invert
While not using DDR:
I) USB port CLK input (48MHz) part I
153 RVREF
V_ADIN3
Analog Inout
Reference voltage for DDR DRAM
While not using DDR :
Version AD input port 3
151 RA3
Inout
DRAM address 3
150 RA2
Inout
DRAM address 2
149 RA1
Inout
DRAM address 1
147 RA0
Inout
DRAM address 0
146 RA10
Inout
DRAM address 10
145 BA1
Inout
DRAM bank address 1
143 BA0
Inout
DRAM bank address 0
92
PD-D6-J
1
2
3
4
5
No.
Name
6
Alt.
7
I/O
8
Function
142 RCS#
output
DRAM chip select, active low
140 RAS#
output
DRAM row address strobe, active low
139 CAS#
output
DRAM column address strobe, active low
138 RWE#
output
DRAM Write enable, active low
137 DQM1
Inout
Data mask 1
Inout
Data strobe 1 for DDR DRAM
While not using DDR:
Microcontroller external interrupt 7
MS Card BS pin part I
GPIO
135 RD8
Inout
DRAM data 8
133 RD9
Inout
DRAM data 9
132 RD10
Inout
DRAM data 10
131 RD11
Inout
DRAM data 11
130 RD12
Inout
DRAM data 12
129 RD13
Inout
DRAM data 13
128 RD14
Inout
DRAM data 14
126 RD15
Inout
DRAM data 15
125 RD0
Inout
DRAM data 0
124 RD1
Inout
DRAM data 1
123 RD2
Inout
DRAM data 2
121 RD3
Inout
DRAM data 3
120 RD4
Inout
DRAM data 4
118 RD5
Inout
DRAM data 5
117 RD6
Inout
DRAM data 6
115 RD7
Inout
DRAM data 7
Inout
Data strobe 0 for DDR DRAM
While not using DDR:
Serial interface port 1 clock pin
MS Card SDIO pin part I
GPIO
Inout
Data mask 0
INT7#
MS_BS
136 DQS1
SCLK1
MS_SDIO
114 DQS0
113 DQM0
A
B
C
D
Other Interface (4)
No.
Name
Alt.
I/O
48 TDI
SDO3
V_ADIN4
SD_DAT
Inout
49 TMS
SDIN3
V_ADIN5
SD_CMD
Inout
50 TCK
SCLK3
V_ADIN6
SDCLK
Inout
51 TDO
SDCS3
V_ADIN7
MSCLK
Inout
Function
GPIO
GPIO
E
GPIO
GPIO
F
93
PD-D6-J
5
6
7
8
1
2
3
4
8. PANEL FACILITIES
Front panel
A
1
2
7
8
3
4
5
6
B
C
1
POWER OFF ON
2
STANDBY indicator
3
Display
4
Disc tray
5
6
/
7
Remote sensor
8
PURE AUDIO indicator
D
E
F
94
PD-D6-J
1
2
3
4
5
6
7
8
Using the remote control
Remote control
1
6
7
8
2
9
3
10
4
11
5
12
Keep in mind the following when using the
remote control:
Make sure that there are no obstacles
between the remote and the remote sensor
on the unit.
The remote has a range of about 23 ft. at an
angle of about 30∫ from the remote sensor.
Remote operation may become unreliable
if strong sunlight or fluorescent light is
shining on the unitís remote sensor.
Remote controllers for different devices
can interfere with each other. Avoid using
remotes for other equipment located close
to this unit.
Replace the batteries when you notice a
fall off in the operating range of the remote.
2
3 4
2
Playback controls
3
Number buttons
4
PROGRAM
5
6
C
LEGATO ALL REPEAT
SACD TOTAL RANDOM
REMAIN PGM
TRACK
B
Display
1
1
A
7
8
1
TRACK - Lights when the track number is
indicated.
RANDOM
2
- Light during playback / when paused.
5
SACD SETUP
3
Scan display - Shows the scan speed.
6
OPEN/CLOSE
4
SACD - Lights during SACD playback.
7
DIMMER
5
8
PURE AUDIO
LEGATO - Lights when Legato Link Pro is
switched on.
9
CLEAR
6
(ALL) REPEAT / RANDOM / PGM - Light to
indicate the playback mode.
7
Character display
8
TOTAL / REMAIN - Indicate the disc/track
information currently displayed.
REPEAT
10 ENTER
11 TIME
12 LEGATO LINK
D
E
F
95
PD-D6-J
5
6
7
8
1
2
3
4
7 Jigs list
A
B
Name
Service Remote Control Unit
DVD Test Disc (DVD-Video)
CD Test Disc
Cable for service (5P)
Jig No.
GGF1381
GGV1025
STD-905
GGD1425
Remarks
adjustment, diagnosis
Check of DVD-Video
Check of CD
Diagnosis of DVDM ASSY
7 Lubricants and Glues list
Name
Lubricating Oil
Daifree
Silicone Adhesive
Screw tight
Lubricants and Glues No.
GYA1001
GEM1036
GEM1037
GYL1001
Remarks
refer to "2.4 05 LOADER ASSY"
refer to "2.4 05 LOADER ASSY"
refer to "2.5 TRAVERSE MECHANISM ASSY-S"
refer to "6.5 MECHANISM ADJUSTMENT"
C
7 CLEANING
Before shipping out the product, be sure to clean the following positions by using the prescribed cleaning tools:
Position to be cleaned
Pickup leneses
D
Cleaning tools
Cleaning liquid : GEM1004
Cleaning paper : GED-008
E
F
96
PD-D6-J
1
2
3
4