Download HCD-LX10000

HCD-LX10000
SERVICE MANUAL
US Model
Ver. 1.1 2008.01
• HCD-LX10000 is the Amplifier,
CD player, tape deck and tuner
section in MHC-LX10000.
CD
Section
TAPE
Section
Model Name Using Similar Mechanism
HCD-GX9900
CD Mechanism Type
CDM74-F1BD81
Base Unit Name
BU-F1BD81A
Optical Pick-up Name
KSM-215DCP/C2NP
Model Name Using Similar Mechanism
HC-GX9900
Tape Transport Mechanism Type
CMAT5Z2
SPECIFICATIONS
AUDIO POWER SPECIFICATION
POWER OUTPUT AND TOTAL HARMONIC
DISTORTION:
With 6-ohm loads, both channels driven, from120 Hz – 10 kHz; rates 230
watts per channelminimum RMS power, with no more than 10% total
harmonic distortion from 250 miliwatts to rated output.
Amplifier section
Total harmonic distortion
Inputs
VIDEO/MD (AUDIO) IN (phono jacks):
TV (AUDIO) IN (phono jack):
MIC (phone jack):
Outputs
PHONES (stereo mini jack):
FRONT SPEAKER:
SURROUND SPEAKER:
Disc player section
System
Laser
Laser Output
Less than 0.1%
(6 ohms at 1 kHz, 100 W)
voltage 250/450 mV,
impedance 47 kiloohms
voltage 250 mV,
impedance 47 kiloohms
sensitivity 1 mV,
impedance 10 kiloohms
accepts headphones of
8 ohms or more
Use only the supplied speaker
Use only the supplied speaker
Compact disc and digital
audio system
Semiconductor laser
(λ=780 nm)
Emission duration:
continuous
Max. 44.6 µW*
*This output is the value
measured at a distance of
200 mm from the objective
9-887-216-02
Sony Corporation
2008A04-1
Audio Business Group
Published by Sony Techno Create Corporation
© 2008.01
Frequency response
Signal-to-noise ratio
Dynamic range
Tape deck section
Recording system
Frequency response
Tuner section
FM stereo, FM/AM superheterodyne tuner
FM tuner section
Tuning range
Antenna
Antenna terminals
Intermediate frequency
AM tuner section
Tuning range
Antenna
Antenna terminals
Intermediate frequency
lens surface on the Optical
Pick-up Block with 7 mm
aperture.
2 Hz – 20 kHz (±0.5 dB)
Wave length 780 – 790 nm
More than 90 dB
More than 90 dB
4-track 2-channel stereo
50 – 13,000 Hz (±3 dB),
using Sony TYPE I tape
87.5 – 108.0 MHz
FM lead antenna
75 ohm unbalanced
10.7 MHz
530 – 1,710 kHz
(with the interval set at 10kHz)
531 – 1,710 kHz
(with the interval set at 9 kHz)
AM loop antenna
External antenna terminal
450 kHz
– Continued on next page –
MiNi Hi-Fi COMPONENT SYSTEM
HCD-LX10000
General
Power requirements
Power consumption
Dimensions (w/h/d) (Approx.)
Mass (Approx.)
Supplied accessories:
120 V AC, 60 Hz
250 watts
280 × 360 × 398.5 mm
15.6 kg
Remote Commander (1)
Batteries (2)
AM loop antenna (1)
FM lead antenna (1)
Front speaker pads (8)
Surround speaker pads (8)
Design and specifications are subject to change without notice.
SAFETY CHECK-OUT
After correcting the original service problem, perform the following
safety checks before releasing the set to the customer:
Check the antenna terminals, metal trim, “metallized” knobs, screws,
and all other exposed metal parts for AC leakage. Check leakage as
described below.
LEAKAGE
The AC leakage from any exposed metal part to earth ground and
from all exposed metal parts to any exposed metal part having a
return to chassis, must not exceed 0.5 mA (500 microamperes).
Leakage current can be measured by any one of three methods.
1. A commercial leakage tester, such as the Simpson 229 or RCA
WT-540A. Follow the manufacturers’ instructions to use these
instruments.
2. A battery-operated AC milliammeter. The Data Precision 245
digital multimeter is suitable for this job.
3. Measuring the voltage drop across a resistor by means of a
VOM or battery-operated AC voltmeter. The “limit” indication
is 0.75 V, so analog meters must have an accurate low-voltage
scale. The Simpson 250 and Sanwa SH-63Trd are examples
of a passive VOM that is suitable. Nearly all battery operated
digital multimeters that have a 2V AC range are suitable. (See
Fig. A)
To Exposed Metal
Parts on Set
0.15 µF
Notes on chip component replacement
• Never reuse a disconnected chip component.
• Notice that the minus side of a tantalum capacitor may be
damaged by heat.
Flexible Circuit Board Repairing
• Keep the temperature of soldering iron around 270˚C
during repairing.
• Do not touch the soldering iron on the same conductor of the
circuit board (within 3 times).
• Be careful not to apply force on the conductor when soldering
or unsoldering.
CAUTION
Use of controls or adjustments or performance of procedures
other than those specified herein may result in hazardous
radiation exposure.
This appliance is classified as
a CLASS 1 LASER product.
This label is located on the rear
exterior.
SAFETY-RELATED COMPONENT WARNING!!
COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE WITH
MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS
LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE
COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS
APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS
PUBLISHED BY SONY.
2
1.5 kΩ
AC
Voltmeter
(0.75 V)
Earth Ground
Fig. A. Using an AC voltmeter to check AC leakage.
Unleaded solder
Boards requiring use of unleaded solder are printed with the lead
free mark (LF) indicating the solder contains no lead.
(Caution: Some printed circuit boards may not come printed with
the lead free mark due to their particular size.)
: LEAD FREE MARK
Unleaded solder has the following characteristics.
• Unleaded solder melts at a temperature about 40°C higher than
ordinary solder.
Ordinary soldering irons can be used but the iron tip has to be
applied to the solder joint for a slightly longer time.
Soldering irons using a temperature regulator should be set to
about 350°C.
Caution: The printed pattern (copper foil) may peel away if
the heated tip is applied for too long, so be careful!
• Strong viscosity
Unleaded solder is more viscous (sticky, less prone to flow)
than ordinary solder so use caution not to let solder bridges
occur such as on IC pins, etc.
• Usable with ordinary solder
It is best to use only unleaded solder but unleaded solder may
also be added to ordinary solder.
HCD-LX10000
TABLE OF CONTENTS
1.
SERVICING NOTES ................................................ 4
2.
GENERAL
Location of Controls ........................................................ 5
3.
DISASSEMBLY
3-1.
3-2.
3-3.
3-4.
3-5.
3-6.
3-7.
3-8.
3-9.
3-10.
3-11.
3-12.
3-13.
3-14.
3-15.
3-16.
3-17.
3-18.
Disassembly Flow ...........................................................
Side Panel, Top Case .......................................................
Loading Panel Assy .........................................................
Front Panel Assy ..............................................................
Tuner Pack .......................................................................
Tape Mechanism Deck, MIC Board ................................
PANEL Board, CD-SW Board ........................................
CD Mechanism Deck ......................................................
Back Panel .......................................................................
PRIMARY Board, LIGHTING Board ............................
Power AMP PC Board Assy, MAIN Board .....................
SURROUND Board, PA Board .......................................
Power Transformer (T1200) ............................................
DRIVER Board, SW Board .............................................
CD Board, Optical Pick-up (KSM-215DCP/C2NP) .......
SENSOR Board ...............................................................
MOTOR (TB) Board .......................................................
MOTOR (LD) Board .......................................................
4.
TEST MODE .............................................................. 17
5.
MECHANICAL ADJUSTMENTS ....................... 21
6.
ELECTRICAL ADJUSTMENTS
7
8
8
9
9
10
10
11
11
12
12
13
13
14
14
15
15
16
Deck section .................................................................... 21
CD Section ...................................................................... 22
7.
7-19.
7-20.
7-21.
7-22.
7-23.
DIAGRAMS ................................................................. 25
Circuit Boards Location .................................................. 26
Block Diagram – CD Section – ...................................... 27
Block Diagram – Tape/Tuner Section – ......................... 28
Block Diagram – Main Section – ................................... 29
Block Diagram – AMP Section – ................................... 30
Block Diagram – Display/Power Section – .................... 31
Printed Wiring Board – CD Board – .............................. 32
Schematic Diagram – CD Board – ................................. 33
Printed Wiring Boards – CD Mechanism Boards – ....... 34
Schematic Diagram – CD Mechanism Boards – ............ 35
Printed Wiring Board – MAIN Board – ......................... 36
Schematic Diagram – MAIN Board (1/3) – ................... 37
Schematic Diagram – MAIN Board (2/3) – ................... 38
Schematic Diagram – MAIN Board (3/3) – ................... 39
Printed Wiring Board – PANEL Board – ....................... 40
Schematic Diagram – PANEL Board – ........................... 41
Printed Wiring Boards – CD-SW, JOG, MIC, LIGHTING
Boards – ........................................................................... 42
Schematic Diagram – CD-SW, JOG, MIC, LIGHTING
Boards – ........................................................................... 43
Printed Wiring Board – PA Board – ............................... 44
Schematic Diagram – PA Board – .................................. 45
Printed Wiring Boards – TRANS, PRIMARY Boards – 46
Schematic Diagram – TRANS, PRIMARY Boards – .... 47
IC Pin Function Description ............................................ 50
8.
EXPLODED VIEWS
7-1.
7-2.
7-3.
7-4.
7-5.
7-6.
7-7.
7-8.
7-9.
7-10.
7-11.
7-12.
7-13.
7-14.
7-15.
7-16.
7-17.
7-18.
8-1.
8-2.
8-3.
8-4.
Case (Top), Back Panel Section ......................................
Front Panel Section .........................................................
Chassis Section ................................................................
CD Mechanism Deck Section-1
(CDM74-F1BD81) ..........................................................
8-5. CD Mechanism Deck Section-2
(CDM74-F1BD81) ..........................................................
9.
56
57
58
59
60
ELECTRICAL PARTS LIST ................................ 61
3
HCD-LX10000
SECTION 1
SERVICING NOTES
NOTES ON HANDLING THE OPTICAL PICK-UP BLOCK
OR BASE UNIT
The laser diode in the optical pick-up block may suffer electrostatic
break-down because of the potential difference generated by the
charged electrostatic load, etc. on clothing and the human body.
During repair, pay attention to electrostatic break-down and also
use the procedure in the printed matter which is included in the
repair parts.
The flexible board is easily damaged and should be handled with
care.
NOTES ON LASER DIODE EMISSION CHECK
The laser beam on this model is concentrated so as to be focused on
the disc reflective surface by the objective lens in the optical pickup block. Therefore, when checking the laser diode emission,
observe from more than 30 cm away from the objective lens.
LASER DIODE AND FOCUS SEARCH OPERATION
CHECK
Carry out the “S curve check” in “CD section adjustment” and check
that the S curve waveform is output several times.
4
HCD-LX10000
SECTION 2
GENERAL
This section is extracted
from instruction manual.
LOCATING THE CONTROLS
List of button locations
ALPHABETICAL ORDER
SYMBOLS
M-R
?/1 (power) ej
Z OPEN/CLOSE 3
n N (play) 8
. > (go backward/forward) qd
m M (rewind/fast forward) qg
X (pause) q;
x (stop) qa
Z A (Eject A) wk
B Z (Eject B) qh
MASTER VOLUME 4
MIC 1 (jack) wd
MIC 2 (jack) ws
MIC LEVEL wa
MP3 BOOSTER 6
OPERATION DIAL wg
PHONES (jack) wf
Power illuminator ql
REC PAUSE/START qs
A-D
ALBUM +/− qg
AMP MENU wl
CD eg
CD SYNC 9
Deck A wj
Deck B qk
DIRECTION qf
DISC 1 ~ 3 1
Disc tray 5
DISPLAY el
Display r;
S-Z
E-L
ECHO LEVEL w;
ENTER qj
EQ BAND 7
EX-CHANGE/DISC SKIP 2
GROOVE es
ILLUMINATION ek
IR Receptor eh
SOUND FLASH wh
SURR SPEAKER MODE ra
TAPE A/B ed
Tape lid qk wj
TUNER/BAND ef
TUNING +/ñ qd
TV ea
VIDEO/MD e;
Top Panel
1
2 3
Front Panel
ra
4
r;
5
el
6
ej
8
ek
7
9
eh
q;
eg
qz
ef
qs
qd
ed
qf
es
ea
qg
e;
wl
qh
wk
qj
wj
qk
wh
wg
ql
wf
wd ws wa w;
5
HCD-LX10000
This section is extracted
from instruction manual.
Remote control
ALPHABETICAL ORDER
A-E
ALBUM + qf
ALBUM − qh
CD wf
CLEAR qk
CLOCK/TIMER SELECT 2
CLOCK/TIMER SET 4
DISC SKIP qd
DISPLAY wh
ENTER qs
EQ qj
F-Z
FM MODE 6
FUNCTION 8
PLAY MODE 5
REPEAT 6
SLEEP 1
6
TAPE wd
TUNER/BAND 7
TUNER MEMORY wg
TUNING MODE 5
VOLUME +/− qg
The + button has a tactile dot.*
SYMBOLS
?/1 (power) 3
x (stop) qa
X (pause) ql
N (play) w;
−. (go backward) ws
>+ (go forward) wa
m (rewind) q;
M (fast forward) 9
1
2
3
4
wh
wg
wf
wd
ws
wa
w;
ql
5
6
7
8
9
q;
qa
qs
qk
qj
qd
qh
qf
qg
* Use the tactile dot as a reference
when operating the system.
HCD-LX10000
SECTION 3
DISASSEMBLY
• This set can be disassembled in the order shown below.
3-1. DISASSEMBLY FLOW
SET
3-2.SIDE PANEL, TOP CASE
(Page 8)
3-3.LOADING PANEL ASSY
(Page 8)
3-4.FRONT PANEL ASSY
(Page 9)
3-5.TUNER PACK
(Page 9)
3-6.TAPE MECHANISM DECK,
MIC BOARD
(Page 10)
3-7.PANEL BOARD,
CD-SW BOARD
(Page 10)
3-8.CD MECHANISM DECK
(Page 11)
3-9.BACK PANEL
(Page 11)
3-11.POWER AMP PC BOARD ASSY,
MAIN BOARD
(Page 12)
3-12.SURROUND BOARD,
PA BOARD
(Page 13)
3-14.DRIVER BOARD,
SW BOARD
(Page 14)
3-10.PRIMARY BOARD,
LIGHTING BOARD
(Page 12)
3-15.CD BOARD,
OPTICAL PICK-UP
(KSM-215DCP/C2NP)
(Page 14)
3-13.POWER TRANSFORMER
(T1200)
(Page 13)
3-16.SENSOR BOARD
(Page 15)
3-17.MOTOR (TB) BOARD
(Page 15)
3-18.MOTOR (LD) BOARD
(Page 16)
7
HCD-LX10000
Note: Follow the disassembly procedure in the numerical order given.
3-2. SIDE PANEL, TOP CASE
7 two screws
(case 3 TP2)
(3 ×12)
qd CASE (TOP)
8 two screws
(+BVTP 3 ×10)
qa two screws
(+BVTP 3 ×10)
9
qs
0 panel (side-R)
2 two screws
(case 3 TP2)
(3 ×12)
6 screw
(case 3 TP2)
(3 × 8)
4
3 two screws
(+BVTP 3 ×10)
5 panel (side-L)
1 screw (case 3 TP2)
(3 × 8)
3-3. LOADING PANEL ASSY
4 loading panel assy
CD mechanism deck (CDM74-F1BD81)
1 Turn the pulley to the arrow direction.
Pulley
3
Front side
2 Pull out disc tray
8
HCD-LX10000
3-4. FRONT PANEL ASSY
7 connector
(CN100)
9 CNP509
4 screw
(+BVTP 3 ×10)
8 CNP508
3 screw
(+BVTP 3 ×10)
lug
qa connector
(CN1102)
6 front panel assy
q; connector
(CN503)
qs connector
(tape mechanism deck)
2 three screws
(+BVTP 3 ×10)
5 screw
(+BVTP 3 × 6)
1 two screws
(+BVTP 3 ×10)
3 tuner pack
3-5. TUNER PACK
2 CNP1
1 two screws
(+BVTP 3 × 6)
4 cover (tuner)
9
HCD-LX10000
3-6. TAPE MECHANISM DECK, MIC BOARD
2 cover (TCM)
1 four screws
(+BVTP2.6 (3CR))
3 screw
(+BVTP2.6 (3CR))
4 tape mechanism deck
5 two screws
(+BVTP2.6 (3CR))
6 bracket (MIC)
8 MIC board
7 two knobs (MIC)
3-7. PANEL BOARD, CD-SW BOARD
qa three screws
(+BV3 (3CR))
7 three screws
(+BVTP2.6 (3CR))
6 two screws
(+BVTP2.6 (3CR))
qs CD-SW board
5 two screws
(+BVTP2.6 (3CR))
4 two screws
(+BVTP2.6 (3CR))
8 connector
(CNS902)
9 claw
0 PANEL board
1 knob vol
2 knob (AMS)
10
3 three screws
(+BVTP2.6 (3CR))
HCD-LX10000
3-8. CD MECHANISM DECK
2 CD mechanism deck
3 CNP505
1 screw
(+BVTP 3 ×10)
4 connector
(CN701)
3-9. BACK PANEL
7 back panel
2 connector
(CN1204)
3 connector
(CN01)
6 two screws
(+BVTP 3 ×10)
1 connector
(CN1200)
5 screw
(+BVTP 3 ×10)
8 connector
(CN580)
4 four screws
(+BVTP 3 ×10)
11
HCD-LX10000
3-10. PRIMARY BOARD, LIGHTING BOARD
1 connector
(CN101)
5 two screws
(+BVTP 3 ×10)
4 PRIMARY board
3 screw
(+BVTP 3 × 8)
2 connector
(CN201)
6 LIGHTING board
3-11. POWER AMP PC BOARD ASSY, MAIN BOARD
5 screw
(+BVTP 3 × 6)
4 two screws
(+BVTP 3 × 6)
7 power AMP PC board assy
3 screw
(+BVTP 3 × 6)
6 screw
(+BVTP 3 ×10)
1 connector
(CN1213)
2 connector
(CN1212)
9 screw
(+BVTP 3 ×10)
q; MAIN board
8 two screws
(+BVTP 3 ×10)
12
HCD-LX10000
3-12. SURROUND BOARD, PA BOARD
2 SURROUND board
1 two screws
(+BVTP 3 ×10)
8 heat sink
3 two screws
(+BVTP 3 ×10)
q; bracket
9 screw
(+BVTP 3 ×10)
4 holder
qa PA board
6 two screws
(transistor)
5 three screws
(+BVTP 3 ×10)
7 two screws
(+BVTP 3 ×10)
3-13. POWER TRANSFORMER (T1200)
4 two screws (+BVTP 4 × 8)
3 two screws
(+BVTP 4 × 8)
TRANS board
5 power transfomer (T1200)
1 connector
(CN1213)
2 connector
(CN1212)
13
HCD-LX10000
3-14. DRIVER BOARD, SW BOARD
3 two screws
(+BTTP (M2.6))
2 cover (CDM)
1 three screws
(+BVTP 3 ×10)
5 connector (CN703)
6 DRIVER board
7 screw
(+BTTP (M2.6))
8 SW board
4 wire (flat type)
(CN702)
3-15. CD BOARD, OPTICAL PICK-UP (KSM-215DCP/C2NP)
qg Remove the four solderings of motor.
qf screw (+BVTP 2.6 × 8)
4 floating screw (+PTPWH M2.6)
5 coil spring (insulator)
qh CN101 (flat type)
7 insulator
qj CD board
9 two screws
(BVTT M2.6)
3 screw
(BVTT M2.6)
6 coil spring
(insulator)
8 insulator
0 two stoppers (BU)
qa two coil springs
(insulator)
qs two insulators
1 floating screw
(+PTPWH M2.6)
qd
qk optical pick-up
(KSM-215DCP/C2NP)
2 holder (213) ASSY
14
HCD-LX10000
3-16. SENSOR BOARD
1 floating screw
(+PTPWH M2.6)
2 tray
8 screw
(+BTTP (M2.6))
3 belt (table)
0 SENSOR board
4 floating screw
(+PTPWH M2.6)
5 pulley (table)
6 floating screw
(+PTPWH M2.6)
9 connector
(CN731)
7 gear (geneva)
3-17. MOTOR (TB) BOARD
2 stopper
4
1 stopper
8 table motor assy (M741)
5 table (loading)
3 wire (flat type) 5 core (CN742)
9 MOTOR (TB) board
7 Remove the two solderings of motor.
6 two screws
(+BTTP (M2.6))
15
HCD-LX10000
3-18. MOTOR (LD) BOARD
3 two screws
(+BTTP (M2.6))
2 Remove the two solderings of motor.
4 MOTOR (LD) board
5 loading motor assy (M751)
1 belt (loading)
16
HCD-LX10000
SECTION 4
TEST MODE
[GC TEST MODE]
• This mode is used to check the fluorescent indicator tube,
LEDs, keys, MASTER VOLUME jog, OPERATION
DIAL jog, AMS jog, destination, software version and
VACS level.
Procedure:
1. Press x button, [ENTER] button and [DISC 2] button
simultaneously.
2. All LEDs and segments in fluorescent indicator tube are lighted
up. All LEDs are lighted up in red color. If the system is turned
on, the `/1 LED is lighted up in green color.
3. When you want to enter the software version display mode,
press [DISC 1] button. The model and destination are displayed.
4. Each time [DISC 1] button is pressed, the display changes from
MC version, GC version, SYS version, CD version, CDDM
version, CDMA version, CDMB version, BDA version, BDB
version, ST version, TC version, TA version and TM version
in this order, and returns to the MC version display.
5. When [DISC 3] button is pressed while the version numbers
are being displayed except model and destination, the date of
the software creation appear. When [DISC 3] button is pressed
again, the display returns to the software version display. When
[DISC 1] button is pressed while the date of the software
creation is being displayed, the date of the software creation
is displayed in the same order of software version display.
6. Press [DISC 2] button, the key check mode is activated.
7. In the key check mode, the fluorescent indicator tube displays
“K 0 J0V0E0 X0”.
Each time a button is pressed, “K” value increases. However,
once a button has been pressed, it is no longer taken into
account.
“J” value increases in the manner of 0,1, 2, 3 ... if [OPERATION
DIAL] knob is turned clockwise, or it decreases in the manner
of 0, 9, 8, 7 ... if [OPERATION DIAL] knob is turned counterclockwise.
“V” value increases in the manner of 0,1, 2, 3 ... if [VOLUME]
knob is turned clockwise, or it decreases in the manner of 0,
9, 8, 7 ... if [VOLUME] knob is turned counter-clockwise.
“E” value increases in the manner of 0,1, 2, 3 ... if . >
knob is turned clockwise, or it decreases in the manner of 0,
9, 8, 7 ... if . > knob is turned counter-clockwise.
8. When [DISC 3] button is pressed after all LEDs and segments
in fluorescent indicator tube light up, the fluorescent indicator
tube displays “VACS A+B APCC”. A is VACS level which is
triggerd by signal level, B is VACS level which is triggerd by
temperature and CC is VACS level which is triggerd by
APVACS (Abuse Protection VACS).
The signal level, which will trigger VACS A is shown in the
center area of fluorescent indicator tube.
9. When [EX-CHANGE/DISC SKIP] button is pressed after all
LEDs and segments in fluorescent indicator tube light up,
alternate segments in fluorescent indicator tube would light
up. If you press [EX-CHANGE/DISC SKIP] button again, another
half of alternate segments in fluorescent indicator tube would
light up. Pressing [EX-CHANGE/DISC SKIP] button again
would cause all segments lights up.
10. To release this mode, press three buttons in the same manner
as step 1, or disconnect the power cord.
[MC TEST MODE]
• This mode is used to check operations of the respective sections
of Amplifier and Tape.
Procedure:
* To enter MC Test Mode
1. Press x button, [ENTER] button and [DISC 3] button
simultaneously.
2. The CD ring indicators, TAPE A and TAPE B indicators flash
on the fluorescent indicator tube. The function is changed to
VIDEO.
* Check of Amplifier
1. Press [EQ BAND] button repeatedly until a message “GEQ
MAX” appears on the fluorescent indicator tube. GEQ
increases to its maximum.
2. Press [EQ BAND] button repeatedly until a message “GEQ
MIN” appears on the fluorescent indicator tube. GEQ decreases
to its minimum.
3. Press [EQ BAND] button repeatedly until a message “GEQ
FLAT” appears on the fluorescent indicator tube. GEQ set to
flat.
4. When the [MASTER VOLUME] knob is turned clockwise even
slightly, the sound volume increases to its maximum and a
message “VOLUME MAX” appears on the fluorescent
indicator tube.
5. When the [MASTER VOLUME] knob is turned counter-clockwise
even slightly, the sound volume decreases to its minimum and
a message “VOLUME MIN” appears on the fluorescent
indicator tub.
* Tape function
1. When a tape is inserted in Deck B and recording is started, the
function is changed to VIDEO automatically. When [CD SYNC]
button is pressed during recording in function, ALC (Automatic
Logic Control) is turned on.
2. During recording, turn m M knob counter- clockwise
will stop the recording and the function is changed to TAPE B
and rewind the tape in deck B until the recording start position
and playback of the tape in deck B is started. If the [REC
PAUSE/ START] button is pressed for a pause and pressed
again to resume recording during recording time, when the
tape in deck B is rewind, the tape in deck B will be rewind
until the position where the pause is applied.
* To release MC Test mode.
1. To release this mode, press ?/1 button.
2. The cold reset is enforced at the same time.
[COLD RESET]
• The cold reset clears all data including preset data stored in
the RAM to initial conditions. Execute this mode when
returning the set to the customer.
Procedure:
1. Press x button, [ENTER] button, and ?/1 button
simultaneously.
2. The fluorescent indicator tube becomes blank for a while, and
the set is reset.
17
HCD-LX10000
[VACS ON/OFF]
• This mode is used to switch ON and OFF the VACS (Variable
Attenuation Control System).
Procedure:
1. Press ?/1 button to turn the set ON.
2. Press x button and [ILLUMINATION] button simultaneously.
The message “VACS OFF” or “VACS ON” appears on the
fluorescent indicator tube.
[TUNER STEP CHANGE]
• The step interval of AM channels can be toggled between 9
kHz and 10 kHz.
Procedure:
1. Press ?/1 button to turn the set ON.
2. Press [TUNER/BAND] button repeatedly to select the “AM”.
3. Press ?/1 button to turn the set OFF.
4. Press [ENTER] button and ?/1 button simultaneously. The
system will turn ON automatically. The message “AM 9k
STEP” or AM 10k STEP” appears on the fluorescent indicator
tube and thus the channel step is changed.
[CD SERVICE MODE]
• This mode let you move the CD sled motor freely. Use this
mode when you want to clean the optical pick-up.
Procedure:
1. Press ?/1 button to turn the set ON.
2. Select CD function.
3. Press x , [ENTER] button, and Z OPEN/CLOSE button
simultaneously on the fluorescent indicator tube.
4. The CD service mode is activated. The message “SERVICE
MODE” appears on the fluorescent indicator tube.
5. With the CD in stop status, turn m M knob clockwise
to move the optical pick-up to outside track, or turn
m M knob counter-clockwise to move to inside track.
The message “SLED OUT” or “SLED IN” appears on the
fluorescent indicator tube.
6. To turn on or off the laser, press [DIRECTION] button. The
message “LD ON” or “LD OFF” appears on the fluorescent
indicator tube.
7. To release this mode, press ?/1 button.
[AGING MODE]
This mode can be used for operation check of CD section.
• If an error occurs, the aging operation would stops and the
status is displayed.
• If there were no error occurs, the aging operation would
continues repeatedly.
Procedure:
1. Press ?/1 button to turn the set ON
2. Select CD function.
3. Load three discs on the disc tray.
4. Press [PLAY MODE] button on the remote repeatedly to select
the “ALL DISCS” mode, and press the [REPEAT] button on
the remote repeatedly to select “REPEAT OFF” mode.
5. Press x button, [ENTER] button and [EX-CHANGE/DISC SKIP]
button simultaneously.
6. Aging operation is started.
7. To release from this mode, press ?/1 button or disconnect
the power cord to turn the power OFF.
Aging mode sequence:
Start (from disc 1)
Disc chucking
TOC reading
Play first track for 2 seconds
Play last track for 2 seconds
EX-CHANGE open/close
Open the disc tray
Disc skip
Close the disk tray
Change the next disc
18
HCD-LX10000
• Display when an error occurred (CD Error Code Mode)
Procedure:
1. Press x button, [ENTER] button and [DISC 1] button
simultaneously to enter the error code display mode.
2. The fluorescent indicator tube displays the number of total
error.
3. Each time m M knob is rotated, display change as
below.
Display of total error
M + direction
>+
– m direction
Display of Mechanical errors
direction
M + direction
>+
–.
direction
– m direction
Display of no disc errors
direction
–.
direction
4. To clear the error record, operate the cold reset. (Refer to the
“MC COLD RESET”)
5. To release this mode, press the ?/1 button or disconnect
the power cord to turn the power OFF.
1) Display of total error
Display
Em**Ed**
Em**: The number of mechanical errors.
Ed**: The number of no disc errors after chucking the disc.
2) Display of mechanical errors
Display
M*$$%%&&##00
M*: The number of mechanical error (“00” is latest one)
(Rotate . > knob in the direction of either to display next
error)
$$: Not used
%%: Loading related error (Second figure is not used)
D: Stop by the problem other than mechanical problem while
closing.
E: Stop by the problem other than mechanical problem while
opening.
C: Stop by the problem other than mechanical problem while
chucking up.
F: Stop by the problem other than mechanical problem while
chucking down.
&&: Emerging error
01: Stop while chucking up.
02: Stop while chucking up.
03: Time-out of EX-CHANGE open.
05: Time-out of EX-CHANGE close.
##: Not used
3) Display of no disc errors
Display
D*$$%%&&##00
D*: The number of no disc error (“00” is latest one)
(Rotate . > knob in the direction of either to display next
error)
$$: Error type
01: Focus error
02: GFS error
03: Setup error
%%: Not used
&&:
00: No disc judgment without chucking retry.
01: No disc judgment after chucking retry.
##: The state when judged as no disc
01: Stop
02: Setup
03: TOC reading
04: Access
05: Playback
06: Pause
07: Manual search (Play)
08: Manual search (Pause)
[CD REPEAT 5 LIMIT OFF MODE]
• The number of repeat for CD playback is 5 times when the
repeat mode is “REPEAT ALL”. This mode enables CD to
repeat playback for limitless times.
Procedure:
1. Press ?/1 button to turn the set ON.
2. Select CD function.
3. Press x button, [CD] button and [DISC 1] button
simultaneously to enter the CD repeat 5 limit off mode and
the message “LIMIT OFF” appears on the fluorescent
indicator tube .
4. To release this mode, operate the cold reset. (Refer to the
“MC COLD RESET”)
[CD SHIP MODE (WITH MEMORY CLEAR)]
• This mode moves the optical pick-up to the position durable
to vibration and clears all data including preset data stored in
the RAM to initial conditions. Use this mode when returning
the set to the customer after repair.
Procedure:
1. Press ?/1 button to turn the set ON.
2. Select CD function.
3. Press x button, [CD] button and ?/1 button simultaneously.
The set will power off automatically.
4. After the “STANDBY” blinking display finishes, a message
“LOCK” appears on the fluorescent indicator tube and the
CD ship mode is set.
19
HCD-LX10000
[CD SHIP MODE (WITHOUT MEMORY CLEAR)]
• This mode moves the optical pick-up to the position durable
to vibration. Use this mode when returning the set to the
customer after repair.
Procedure:
1. Press ?/1 button to turn the set ON.
2. Select CD function.
3. Press [CD] button and ?/1 button simultaneously. The set
will power off automatically.
4. After the “STANDBY” blinking display finish, a message
“LOCK” appears on the fluorescent indicator tube and the
CD ship mode is set.
[CD POWER MANAGE]
• This mode let you switch on or off power supply to the BU
during TUNER function.
• When CD POWER is set to OFF, the power supply to the BU
is cut off during TUNER function. It will increase the time
taken to access CD when function change from TUNER to
CD but it will improve tuner reception.
• When CD POWER is set to ON, the power supply to the BU
is not cut off during TUNER function. It will reduce the time
taken to access CD when function change from TUNER to
CD but it will decrease tuner reception performance.
Procedure:
1. Press ?/1 button to turn the set ON.
2. Select CD function.
3. Press ?/1 button to turn the set OFF.
4. Press x button and ?/1 button simultaneously. The set
will power on automatically.
5. The message “CD POWER ON” or “CD POWER OFF” will
be displayed on the fluorescent indicator tube.
20
[CD TRAY LOCK MODE]
• This mode let you lock the disc tray. When this mode is
activated, the disc tray will not open when Z OPEN/CLOSE
button or [EX-CHANGE/DISC SKIP] button is pressed. The
message “LOCKED” will be displayed on the fluorescent
indicator tube.
Procedure:
1. Press ?/1 button to turn the set ON.
2. Select CD function.
3. Press x button and Z OPEN/CLOSE button
simultaneously and hold down until “LOCKED” or
“UNLOCKED” appears on the fluorescent indicator tube
(around 5 seconds).
[VIDEO/MD SWITCHING]
• This mode let you switch from VIDEO to MD and vice-versa.
Procedure:
1. Press ?/1 button to turn the set ON.
2. Select VIDEO function.
3. Press [VIDEO/MD] button and ?/1 button simultaneously.
The function will change to MD. Press the same buttons again
to change from MD to VIDEO.
[REMOTE COMMANDER DISABLE MODE]
• This mode let you disable the remote commander reception.
When this mode is activated, the set will not response if the
button on the remote commander is pressed. The message
“RemoteDisable” will be displayed on the fluorescent indicator
tube. Use this mode during aging to avoid disturbance.
• Procedure:
1. Press x button, [GROOVE] button and [DISC 2] button
simultaneously.
The message “RemoteDisable” appears on the fluorescent
indicator tube. To enable the remote commander reception,
press the same buttons again.
The message “RemoteEnable” appears on the fluorescent
indicator tube.
HCD-LX10000
SECTION 5
MECHANICAL ADJUSTMENTS
Precaution
1. Clean the following parts with a denatured alcohol-moistened
swab:
record/playback heads pinch rollers
erase head
rubber belts
capstan
idlers
2. Demagnetize the record/playback head with a head
demagnetizer.
3. Do not use a magnetized screwdriver for the adjustments.
4. After the adjustments, apply suitable locking compound to
the parts adjusted.
5. The adjustments should be performed with the rated power
supply voltage unless otherwise noted.
Torque Measurement
Mode
FWD
FWD
back tension
REV
Torque meter
CQ-102C
CQ-102C
CQ-102RC
REV
back tension
FF/REW
CQ-102RC
CQ-201B
Meter reading
2.94 to 7.84 mN • m
30 to 79 g • cm
(0.43 to 1.09 oz • inch)
0.15 to 0.59 mN • m
1.6 to 6 g • cm
(0.03 to 0.08 oz • inch)
2.94 to 7.84mN • m
30 to 79 g • cm
(0.43 to 1.09 oz • inch)
0.15 to 0.59 mN • m
1.6 to 6 g • cm
(0.03 to 0.08 oz • inch)
6.86 to 17.64 mN • m
70 to 179 g • cm
(0.98 to 2.48 oz • inch)
SECTION 6
ELECTRICAL ADJUSTMENTS
DECK SECTION
0 dB=0.775 V
1. Demagnetize the record/playback head with a head
demagnetizer.
2. Do not use a magnetized screwdriver for the adjustments.
3. After the adjustments, apply suitable locking compound to the
parts adjust.
4. The adjustments should be performed with the rated power
supply voltage unless otherwise noted.
5. The adjustments should be performed in the order given in
this service manual. (As a general rule, playback circuit
adjustment should be completed before performing recording
circuit adjustment.)
6. The adjustments should be performed for both L-CH and RCH.
7. Switches and controls should be set as follows unless otherwise
specified.
• Test Tape
Tape
P-4-A100
Signal
10 kHz, –10 dB
Used for
Azimuth Adjustment
RECORD/PLAYBACK HEAD AZIMUTH ADJUST-MENT
DECK A
DECK B
Note: Perform this adjustments for both decks
Procedure:
1. Mode: Playback
test tape
P-4-A100
(10 kHz, –10 dB)
MAIN board
CN510
Pin 1 (L-CH)
Pin 3 (R-CH) level meter
set
+
–
MAIN board
CN510
Pin 2 (GND)
21
HCD-LX10000
2. Turn the adjustment screw and check output peaks. If the peaks
do not match for L-CH and R-CH, turn the adjustment screw
so that outputs match within 1dB of peak.
within
1dB
L-CH
peak
within
1dB
Output
level
Screw
position
CD SECTION
Note:
1. CD Block is basically designed to operate without adjustment.
Therefore, check each item in order given.
2. Use YEDS-18 disc (3-702-101-01) unless otherwise indicated.
3. Use an oscilloscope with more than 10MΩ impedance.
4. Clean the object lens by an applicator with neutral detergent
when the signal level is low than specified value with the
following checks.
S-curve Check
Connection:
R-CH
peak
L-CH
peak
Screw
position
R-CH
peak
CD board
3. Mode: Playback
test tape
P-4-A100
(10 kHz, –10 dB)
L-CH
MAIN
board
CN510
set
oscilloscope
TPO102 (FE1)
TP117 (VC)
oscilloscope
pin 1
pin 2
L
V
H
R
R-CH
pin 3
waveform of oscilloscope
in phase 45 °
good
90 ° 135 ° 180 °
+
–
Procedure:
1. Connect an oscilloscope to test point TPO102 (FE1) and TP
117(VC) on the CD board.
2. Turn the power on.
3. Put the disc (YEDS-18) in and turned power switch on again
and actuate the focus search. (actuate the focus search when
disc table is moving in and out)
4. Check the oscilloscope waveform (S-curve) is symmetrical
between A and B. And confirm peak to peak level within
2.4 ± 1 Vp-p.
S-curve waveform
symmetry
wrong
4. After the adjustments, apply suitable locking compound to
the pats adjusted.
Adjustment Location: Playback Head (Deck A).
Record/Playback/Erase Head (Deck B).
A
B
Note:
• Try to measure several times to make sure than the ratio
of A : B or B : A is more than 10 : 7.
• Take sweep time as long as possible and light up the
brightness to obtain best waveform.
Checking Location: CD board (SIDE B)
(See page 24.)
forward
22
reverse
within 2.4 ± 1 Vp-p
HCD-LX10000
E-F Balance Check
Connection:
RFAC Level Check
Connection:
oscilloscope
oscilloscope
CD board
CD board
TP124 (RFAC)
TP117 (VC)
TPO103 (TE1)
TP117 (VC)
+
–
Procedure:
1. Connect an oscilloscope to test point TP124 (RFAC) and TP
117(VC) on the CD board.
2. Turn the power on.
3. Put the disc (YEDS-18) in to playback the number five track.
4. Confirm that oscilloscope waveform is clear and check RFAC
signal level is correct or not.
Note:
A clear RFAC signal waveform means that the shape “◊” can be
clearly distinguished at the center of the waveform.
RFAC signal waveform
VOLT/DIV: 200 mV
TIME/DIV: 500 ns
level: 0.9 ± 0.4 Vp-p
+
–
Procedure:
1. Connect an oscilloscpe to test point TPO103 (TE1) and TP117
(VC) on the CD board.
2. Turn the power on.
3. Select the function “CD”.
4. Press three buttons of [ENTER], M , and
[SURRUUND MODE] simultaneously to set the CD service
mode.
5. Put the disc (YEDS-18) in to playback the number five track.
6. Press the . button. The message “TRAVERSE” is
displayed. (The tracking servo and the sledding servo are
turned OFF)
7. Check the level B of the oscilliscope's waveform and the A
(DC voltage) of the center of the Traverse waveform.
Confirm the following :
A/B x 100 = less than ± 22%
Center of
the waveform
Traverse Waveform
B
Checking Location: CD board (SIDE B)
(See page 24.)
A (DC
voltage)
0V
level: 1.0 ± 0.5 Vp-p
8. Press the . button. The message “TRAVERSE” is
displayed. (The tracking servo and sledding servo are turned
ON)
Confirm the C (DC voltage) is almost equal to the A (DC
voltage) is step 5.
9. To exit from this mode, perform as follows.
1) Move the optical pick-up to the most inside track.
2) Press three buttons of x , [CLEAR], and [DISPLAY]
simultaneously. (cold reset)
Notes:
•
•
Always move the optical pick-up to most inside track
when exiting from this mode. Otherwise, a disc will not
be unloaded.
Do not run the sled motor excessively, otherwise the gear
can be chipped.
Traverse Waveform
C (DC
voltage)
0V
Tracking servo
Sled servo
OFF
Tracking servo
Sled servo
ON
Checking Location: CD board (SIDE B) (See page 24.)
23
HCD-LX10000
Checking Location:
– CD BOARD (SIDE B) –
TP117 (VC)
JPO103 (TE1)
IC101
JPO102 (FE1)
TP124 (RFAC)
24
HCD-LX10000
SECTION 7
DIAGRAMS
For schematic diagrams.
Note:
• All capacitors are in µF unless otherwise noted. (p: pF)
50 V or less are not indicated except for electrolytics and
tantalums.
• All resistors are in Ω and 1/4 W or less unless otherwise
specified.
•
%
: indicates tolerance.
•
f
: internal component.
• 2 : nonflammable resistor.
• 5 : fusible resistor.
Note: The components identified by mark 0 or dotted line
with mark 0 are critical for safety.
Replace only with part number specified.
•
•
•
•
•
•
•
•
C : panel designation.
A : B+ Line.
B : B– Line.
Voltages and waveforms are dc with respect to ground
under no-signal conditions.
CD board
no mark: CD PLAY
Other board
no mark: TUNER (FM/AM)
(
) : CD PLAY
<
> : TAPE PLAY
[
] : TAPE REC
*
: Impossible to measure
Voltages are taken with a VOM (Input impedance 10 MΩ).
Voltage variations may be noted due to normal production tolerances.
Waveforms are taken with a oscilloscope.
Voltage variations may be noted due to normal production tolerances.
Circled numbers refer to waveforms.
Signal path.
F
: TUNER (FM/AM)
E
: TAPE PLAY (DECK A)
d
: TAPE PLAY (DECK B)
G
: RECORD
J
: CD PLAY
N
: MIC INPUT
Note on Printed Wiring Boards:
Note:
• X : parts extracted from the component side.
•
: Pattern from the side which enables seeing.
(The other layers' patterns are not indicated.)
Caution:
Parts face side:
(Side A)
Pattern face side:
(Side B)
Parts on the parts face side seen from
the parts face are indicated.
Parts on the pattern face side seen from
the pattern face are indicated.
• Indication of transistor.
C
Q
These are omitted.
B E
Q
B C
E
These are omitted.
Q
B
C
E
These are omitted.
25
HCD-LX10000
7-1. CIRCUIT BOARDS LOCATION
PRIMARY board
CD-SW board
TUNER PACK
LIGHTING board
TRANS board
SWITCHING POWER
SURROUND board
PA board
SENSOR board
SW board
MOTOR (LD) board
CD board
MOTOR (TB) board
DRIVER board
PANEL board
JOG board
MAIN board
MIC board
26
HCD-LX10000
7-2. BLOCK DIAGRAM
– CD SECTION –
AOUT2 86
OPTICAL PICK-UP
BLOCK
(KSM-215DCP/C2NP)
MAIN
SECTION
(Page 29)
A
CD-L
AOUT1 81
R-CH
IC101
CD MUTE
Q250,251
RF AMP,
DSP,DAC
CD MUTE DRIVE
Q540, 541
DETECTOR
VCC
+3.3V
IC301
VC
MP3 DECODER
25 VC
IC303
A
26 A
PCMD1 61
B
27 B
11 SDO0
VDD 55
LRCKI 62
16 LRCKIA
VDD 21
C
28 C
LRCK 63
19 SFSY/LRCK1B
D
29 D
PCMD 65
14 SDI0
E
19 E
BCK 66
F
20 F
BCK1 60
5
REG
1
+3.3V
VDDM 40
15 BCKIA
18 SBSY/BCK1B
IC701
Q10
STANBY 3
MIACK 8
MICK 7
DATA 102
IC251
XLAT 104
SL/SP MOTOR
DRIVER
F+
FOCUS
COIL
F
T+
TRACKING
COIL
T
OUT
12 CH2OUT-F VREF 26
CH1FIN 4
XRST 100
CLOCK 105
SENS 107
11 TFDR
SCOR 115
XTCN
MICS 4
XRST
RESET 2
DATA
SRMSTB 41
MP3 CS
MP3 RST
XLT
SCOR
CLOCK
SENS
SENS
CLOCK
SCOR
XLT
DATA
12 TRDR
XTCN
13 CH1OUT-R
22 MP3 RST
14 FRDR
1 XRST
SYSTEM
CONTROL
10 SRDR
VMUTE
CH3RIN 22
E-3
ROTARY
E-2 ENCODER
E-1
S751
(OPEN)
RESET
IIC-DATA
IIC-CLK
17 CH3OUT-F
M102
(SLED)
M
DISPLAY/TUNER
SECTION
(Page 31)
B
NO402
OPIN+ 2
6 MPD
18 CH3OUT-R
MUTE 20
S101
(LIMIT)
D+3.3V
RE701
28 XTCN
CDG-DET
16 CH4OUT-F
M741
(TABLE)
OUT1 4
OUT2 2
34 33 31 32 9
9 SFDR
M
INVERTER
Q731
IC401 (1/5)
CDG/_BGC
CH3FIN 23
M751
(TABLE LOADING)
IC731
18 CD-CLK
2 CD-DATA
M
(TABLE SENSOR)
15 CH4OUT-R
M101
M
(SPINDLE)
9 RIN
7 FIN
E-3 40
OPEN SW 38
21 SENS
37 CD MUTE
CH2RIN 7
IC712
E-2 41
19 SCOR
OUT1 4
OUT2 2
TBL MOTOR DRIVER
TBL_SENS 39
E-1 42
23 MP3 CS
13 FFDR
14 CH1OUT-F
9 RIN
7 FIN
TM-R 44
TM-F 43
24 MP3 LP
3 XLAT
XRST
CH2FIN 6
7 MP3 CLK
5 MP3 DATA OUT
6 MP3 DATA IN
11 CH2OUT-R
CH1RIN 5
LMF 45
CNVCC
VR
MILP 5
XTACN 95
37 PD
MP3 LP
LMR 46
25 MP3 ACK
CNVCC
78 XTAI
PD
MP3 DATA
MIDIO 6
26 MP3 REQ
VMUTE
77 XTAO
X171
16.9MHz
MP3 CLK
27 MP3 STB
CD POWER
GND
MP3 REQ
MP3 ACK
PO11/BUCK/AD1 36
CDG-POWER
36 LD
CDG/BGC
LD
DRIVER
(LD)MOTOR DRIVER
CDG DET
LD
MP3 STB
3
IIC-CLK
4
IIC-DATA
100 XRST
VMUTE
7 SSTP
CN402
2 TXD1
CDG/_BGC
3
CDG/-DET
6
CDG/-POWER
7
CNVSS
8
9
RTS1
CLK1
ON BOARD
PROGRAM
RXD1
CN VSS
RESET
• R-CH is omitted due to same as L-CH.
• SIGNAL PATH
: CD
HCD-LX10000
27
27
HCD-LX10000
7-3. BLOCK DIAGRAM
– TAPE/TUNER SECTION –
DECK-A
32
L – CH
AIN1
PB
HEAD
A
R-CH
34
Q376
TC-PB-L
26
MUTE
Q280
L
R-CH
IC301
R
MAIN
SECTION
(Page 29)
TEST
CONNECTOR
MUTE DRIVE
Q542, 543
DECK A/B SELECT
PB/REC EQUALIZER AMP
SWITCH
DRIVE
Q377, 379
BIAS
TRAP
21
T301
REC-OUT1
BIAS+9V
BIAS OSC
Q370
Q378,380
REC IN1
EQ
MUTE ON/OFF
C174, L104
REC MUTE ON/OFF
R-CH
ERASE
HEAD
C
CN510
Q381
R-CH
PB OUT1
R-CH
REC/PB
HEAD
R – CH
TAI1
BIN1
Q373, 374
L – CH
27
ALC ON/OFF
DECK-B
SWITCH
DRIVE
Q382, 383
28
A/B
R – CH
EQ OUT1
B
13
11
15
14
REC-OUT-L
24
D
MAIN
SECTION
(Page 29)
IC401(2/5)
SYSTEM CONTROL
(CD/TAPE MECHANISM CONTROL)
65 TC-MUTE/IO-EXP DATA OUT
67 REC-MUTE
58 ALC
TAPE
MECHANISM
BLOCK
59 PB-A/B
56 REC BIAS
REC(REV)
REC(FWD)
90
89
51
47
94
48
57
53
B SHUT
A SHUT
BPLAY
APLAY
BHALF
AHALF
Q340, 343
A TRIG
DRIVE
ATRGM+
BSHUT
ASHUT
B-PLAY
A-PLAY
B-HALF
A-HALF
TC-RELAY
A-TRIG
Q342, 345
B TRIG
DRIVE
Q341,344
BTRGM+
55 B-TRIG
CAP MOTOR
DRIVE
CAP M+
54 CAPM-CONT
FM/AM TUNER UNIT
ST-L
ST-L
FM ANT
FM 75
COAXIAL
ST-R
E
MAIN
SECTION
(Page 29)
R-CH
88 TUNED
TUNED
AM ANT
AM
AM ANT
ANTENNA
87
85
86
84
ST-DIN
ST-DOUT
ST-CLK
ST-CE
HCD-LX10000
28
28
MC DOUT(ST)
MC DIN(ST)
ST-CLK
ST-CE
• R-CH is omitted due to same as L-CH.
• SIGNAL PATH
: TUNER (FM/AM)
: PLAYBACK (DECK A)
: PLAYBACK (DECK B)
: RECORD
HCD-LX10000
7-4. BLOCK DIAGRAM
– MAIN SECTION –
J1100(1/3)
MIC 1
RV1100
MIC LEVEL
J1101(1/3)
MIC 2
3
IC1100 (1/2)
MIC AMP
+
1
6
IC1100 (2/2)
MIC AMP
REC-OUT-L
MIC OUT
7
J1101(2/3)
2
J1101(3/3)
LPF1 IC1101 LPF2
DIGTAL OUT 9
IN
ECHO
R-CH
RV1101
ECHO LEVEL
INPUT SELECT SWITCH,
GRAPHIC EQUALIZER CONTROL,
ELECTRICAL VOLUME
C
A
B
MID/
BASS &
TREBLE
J101
TV
AUDIO
IN
24
VOLIN1
TOUT1
14
15
VOLUME
CONTROL
OUT1
18
J01
7
L
INEX1
COMMAND
R-CH
+
SAOUT
19
+
1
CPU
INTERFACE
21
22
16
L+R
BB-B1
SURROUND OR
DPL BUFFER
R-CH
R-CH
+
BB-A1
INPUT
SELECT
SWITCH
C
A
B
CLK
R-CH
IND1
6
INB1
4
INA1
3
INC1
5
DATA
L
R
SWOUT
+
8
RECB1
IC101
MIC
2
R
TAPE/TUNER
SECTION
(Page 28)
J1100(3/3)
J1100(2/3)
VIDEO/MD
AUDIO
IN
D
A+9V
+4V REG
Q01
D+4V
D-LIGHT
SYNC OUT
5 GND
17
Q101
TAPE/TUNER
SECTION
(Page 28)
C
TC-PB-L
TAPE/TUNER
SECTION
(Page 28)
E
ST-L
CD SECTION
(Page 27)
A
CD-L
A+9V
R-CH
SPEANA
DBFB F/B
F
DISPLAY/POWER
SECTION
(Page 31)
G
AMP
SECTION
(Page 30)
H
AMP
SECTION
(Page 30)
F-R
R-CH
MUTE
Q180, 181
F-L
IC401
(3/5)
SYSTEM CONTROL
81
82
M61529-CLK
LINE MUTE
66
M61529-DATA
Q544,545
BUFFER
• R-CH is omitted due to same as L-CH.
• SIGNAL PATH
: TUNER (FM/AM)
: CD
: TAPE PLAY
: RECORD
: MIC INPUT
HCD-LX10000
29
29
HCD-LX10000
7-5. BLOCK DIAGRAM
– AMP SECTION –
MAIN
SECTION
(Page 29)
G
DBFB F/B
J1103
PHONES
IC600
POWER AMP
18
F-L
MAIN
SECTION
(Page 29)
H
14
F-R
D624
11
10
+
TM600
+
+
+
-
+
8
9
RY646
12
MUTING
Q640, 641
THERMAL
DETECT
Q628, 630
STK MUTE
FRONT SPEAKER
R
TM601
MUTING
CONTROL
Q634,682
+
+
-
RELAY DRIVE
Q644, 647
H/P DET
TH629
F-RELAY
MUTING
Q604, 606, 610
OVER LOAD
DETECT
Q668, 618
L
L
SURR SPEAKER
R
RY665
RELAY DRIVE
Q666
4
3
CT
OUT
VP
DC DET
OCP
OVER
LOAD
2
FAN DET
FAN-ON
FAN-K
D550
FAN MOTOR
DRIVE
Q580,582,584,585
M
M891
DC FAN
FAN-CTL
I
HP-MUTE
1
Q583
IC550
OVER CURRENT
PROTECTOR
VL(AC)
Q648
HCD-LX10000
30
30
76
100
HD DETT
HP-DET
36
FR-RELAY
F-RELAY
75
FAN KICK-OFF
HP-MUTE
77
HP-MUTE
PROT
IC401 (4/5)
SYSTEM CONTROLLER
52
LINE/SURR-RLY
70
THERMAL VACS
78
STK-MUTE
STK-MUTE
THERMAL
DETECT
Q629
FAN-K
TH630
• SIGNAL PATH
: FM
J
DISPLAY/POWER
SECTION
(Page 31)
DISPLAY/POWER
SECTION
(Page 31)
HCD-LX10000
– DISPLAY/POWER SECTION –
KEY2
|
KEY0
83 XIN
X901
4MHz
64 – 66
7-6. BLOCK DIAGRAM
LED+9V
S1149-1160
S910,911,918,920,924
S901 – 904, 912,915,917
82 XOUT
G14-16
BUFFER
Q901,902,914
G1-13,G17-24
VF1
VF2
Q906
SELECTOR 80
P1 – 36
Q904
IC902
DISPLAY CONTROL
KEY CONTROL
G14-16
57– 59,
72,78,79
FL901
FLUORESCENT
INDICATOR TUBE
8 – 1, 100 – 96,
92-85
P1 – 36
93–95
9,10, 12 – 22,
24 – 41, 43 – 47
Q905
Q907
LED DRIVE
Q908-913,915,
916,918-920
D906, 908 – 913
D 917,
D925,920,922,924
G1 – 13
G17-24
D907,
D914,915,916,918,
D919,921,923,926
LED VIDEO 55
D905
-VG
(-32V)
48 VKK
BPF
2 IN2
X
F
AMP
SECTION
(Page 30)
LED TUNER 53
IC904
MAIN
SECTION
(Page 29)
LED CD/DVD 52
SPEANA
16
68 BPF4
15
69 BPF3
14
70 BPF2
13
71 BPF1
17
67 ALL BAND
LED TAPE 54
T1200
POWER
TRANSFORMER
+VL
IIC-DATA
IIC-CLK
B
F1261
VL
F1271
VL
GND
RECT
D658
–VL
RESET
OPERATION
DIAL
VL(AC)
LED STOP,PAUSE 56
1 IN1
ROTARY
ENCODER
S1161
D660, 661
X
J
F1241
CD
SECTION
(Page 27)
+VH
–VH
VH
F1251
R1292
– 35V
REGULATOR
Q1264
– VG
(-32V)
75 JOG
VH
RECT
D656
VP
D1292
RECT
IC401 (5/5)
SYSTEM CONTROL
VOLUME
ROTARY
ENCODER
S970
74 VOLUME
TO FLUORESCENT
INDICATOR TUBE
FL901
30 IIC-DATA
29 IIC-CLK
71 GC-RESET
IIC DATA 60
IIC CLK 61
RESET 77
D561 – 563
ROTARY
ENCODER
S916
IC561
BIAS+3.3V
A +9V
TC +9V
D927
(G)
XI
IC560
+9V
REGULATOR
97 BPM DET
D902
(R)
AMP
SECTION
(Page 30)
+9V
REGULATOR
76 AMS
BPM LOW
LED DRIVE
Q900,903,917
VF
VF2
MT +7V
LED+9V
M +9V
. - TUNING + >
VF
VF1
IC562
+3.3V
72 STBY-LED/FAN CTL
+3.3V
REGULATOR
F1281 AC3
RECT
D560
AC3
B+ SWITCH
Q560, 561
CD-POWER 32
FAN CTL
S925
NC
NC
AC4
AC4
74 POWER-KEY
73 DISPLAY-KEY
S900
DISPLAY
POWER ON/OFF
RELAY DRIVE
Q1200
STBY-RY 69
B+ SWITCH
Q504, 505
D3.3V
IC903
4 SIRCS
REMOTE CONTROL
RECEIVER
RY1200
D505
M+9V
EVER +4V
15 X-IN
X402
16MHz
RESET
SWITCH
Q501
RESET 12
13 X-OUT
10 XC-IN
X401
32.768kHz
AC-CUT 20
11 XC-OUT
HCD-LX10000
31
31
1
IC402
LEVEL
DETECT
2
SWITCHING
REGULATOR
AC IN
HCD-LX10000
• See page 26 for Circuit Boards Location.
7-7. PRINTED WIRING BOARD – CD BOARD –
3
2
1
: Uses unleaded solder.
4
5
6
8
7
9
10
A
CD BOARD (SIDE A)
CD BOARD (SIDE B)
M
M101
(SPINDLE)
C302
IC303
S101
(LIMIT)
C305
B
3
1
4
5
TP124
(RFAC)
OPTICAL PICK-UP
BLOCK
(KSM-215DCP)
R132
C122
C123
R133
C143
R142
C141
C142
R151
C132
R143 R141
C133
1-860-502-
R131
C131
Q10
E
CN101
C124
C16
13
(13)
MAIN
BOARD
CN505
(Page 36)
C185 C186
R161
R111
C111
CN201
R182
R412
C162 C181
R112
C17
R406
C194
C114
C113
R113
R114
C115
IC101
A
27
R204
C211
R163
R410
R407
1
R401
R181
R307
C307
C311 R306
C212
R409
R408
C213
R303
C161
R10 R13
C11
C18
R11
R12
C10
C112
C15
C125
C134
R121
48
C163
JPO102
(FE1)
C195
C317
R305
R402
49
33
R411
R251
C196
C14
R173
C174
R171
X171
C209
E
32
C310
TP117
(VC)
R301
IC301
JPO103
(TE1)
C172
C151
14
M102
(SLED)
M
64
R252
R191
R172
C203
8
C309
C116
C171
C201
1
16
C320
7
1
C251
C258
C259
C182
R201
C313
17
C210 R162
R165
FB301
D
R404
IC251
R353
C318
C183
R419 R403
C306
C308
R205
15
21
R352
C312
C184
22
28
C257
R253
R354 R405
R302
C314
R351
C260
R313
C315
C316
C
C252
C255
C303
R203
1-860-502-
13
(13)
• Semiconductor
Location
Ref. No.
F
HCD-LX10000
32
32
Location
IC101
IC251
IC301
IC303
D-8
C-6
C-8
B-8
Q10
E-4
HCD-LX10000
• See pages 48 and 49 for IC Block Diagrams. • See page 48 for Waveforms.
7-8. SCHEMATIC DIAGRAM – CD BOARD –
• See page 50 for IC Pin Function Description.
CN101
16P
C151
100
10V
R351 100
R302
10k
R303 100k
MP3 DECODER
C310
0.1
MP3 CLK
MP3 DATA
R419 100
MP3 LP
R403 100
MP3 CS
TP124 RFAC
R121 15k
C18 0.001
TP121
RFDCO
R353 100
R354 100
C161 0.1
C318
0.01
R111 1k
TP301
R161 100
JPO103 TEI
X171
16.9MHz
R171
470
R172 1M
C195 0.1
R181 100
C185
470p
C186
470p
C181
0.1
C182
0.1
C183 22 6.3V
C184 22 6.3V
S101
TP167
LOCK
R182 100
FB301
BLM21B272S
C302
0.1
C303
0.1
TP117
VC
RF AMP, DSP, DAC
C172 27p
R173
0
C112
470p
C113
0.0033
C114
470p
C116
100
10V
C115 0.1
C171
22p
C314
47 4V
R114 15k
IC101
CXD3059AR
C162 0.1
C320
0
C174
0.1
C312
0.1
C111 0.0033
R112 15k
JPO102 FEI
R113 1k
C313 0.1
IC303
BH15FB1WG
OPTICAL
PICK-UP
BLOCK
(KSM-215DCP)
R352 100
C317
0.01
R313 C315
220 0.1
C14
0.1
C123
0.1
R132
10k
R305 100k
R306
0
Q10
2SA2119K
R11
0
C122
0.1
R301 100k
C311
0.1
R13
1
R10
3.3
MP3 ACK
R405 100
R402 100
C316
0.0022
C16
1
C306
0.1
R404 100
R401 100
R133
180k
C17
220
4V
JPO10
APC
C124 330p
R141 4.7k
TP303
IC301
TC94A34FG-002
C309
0.1
C141
0.1
R142
1k
R151
0
C133
0.01
C131 100p
C143
0.1
TP302
C308
47 4V
R12
100k
C132
0.47
R143
3.3k
R203
0
C125
0.1
C134
0.1
C11 10
C142
0.0015
TP304
R131 1M
C307
0.1
C10 10
C15
0.1
R307 10k
TP178
FOK
TP166
DFCT
C305
220
4V
TP165
MIRR
TP160
WDCK
TP162
COUT
TP153 GFS
TP146 C2PO
TP144 XUGF
TP147 XPCK
R191
0
C163
0.1
R165
0
TP145 WFCK
TP142
TP148 SBSO
TP149 EXCK
C194
0.1
R252
22k
R251
10k
JPO004
MDP
C251
0.0068
R163
100
R162
47k
C258
0.1
C259
0.1
C196 0.1
C210
0.1
CN201
27P
R253
10k
IC251
BA5947FM-E2
MP3 ACK
MP3 ACK
MP3 CLK
MP3 CLK
R201
0
MP3 DATA
MP3 DATA
C203
100
10V
MP3 LP
MP3 LP
MP3 CS
MP3 CS
C201
100
10V
C209
0.01
MAIN
BOARD
(2/3)
CN505
(Page 38)
R205 0
R411 100
M101
(SPINDLE)
R410 100
R409 100
R408 100
C257
0.1
R407 100
R406 100
C213 22p
R412 100
C212 22p
C260
220 10V
C211 220p
R204
0
HCD-LX10000
33
33
C255
0.1
C252
0.1
M102
(SLED)
HCD-LX10000
7-9. PRINTED WIRING BOARDS – CD MECHANISM BOARDS –
3
2
1
• See page 26 for Circuit Boards Location.
4
: Uses unleaded solder.
5
6
DRIVER BOARD
CN702
C751
CN704
M741
(TABLE)
CN705
R733
CN703
R734
C736
C735
R732
R735
C737
B
Q731
CN742
JW710
M751
(TABLE LOADING)
R751
R723
JW709
R713
D711
R701
D701
R702
JW708
C752
JW712
R721
CN721
CN741
JW711
C741
R722
C
9
MOTOR(TB)
BOARD
A
MOTOR(LD) BOARD
8
7
JW707
JW706
C715
SENSOR BOARD
JW705
R711
IC731
R712
JW714
JW704
IC712
IC701
D
CN701
JW713
JW703
MAIN
BOARD
NO507
(Page 36)
CN731
JW702
R731
C731
JW701
SW BOARD
CN751
S751
(OPEN)
E
• Semiconductor
Location
Ref. No.
HCD-LX10000
34
34
Location
D701
D711
C-4
C-4
IC701
IC712
IC731
D-4
D-5
C-7
Q731
B-6
HCD-LX10000
7-10. SCHEMATIC DIAGRAM – CD MECHANISM BOARDS –
• See page 48 for IC Block Diagrams.
IC701
BA6956AN
R702
100
RIN
GND
FIN
VCC
VM
OUT1
RNF
OUT2
VREF
TABLE LOADING
MOTOR DRIVER
C715
100
16V
CN701
12P
R701
470
D701
MTZJ-T-72-5.1A
MAIN
BOARD
(1/3)
NO507
(Page 37)
IC712
BA6956AN
M751
(TABLE LOADING)
C751
0.01
CN704
2P
RIN
GND
FIN
VCC
VM
OUT1
RNF
OUT2
TABLE MOTOR
DRIVER
VREF
CN721
2P
C752
0.1
S751
(OPEN)
R712
4.7k
R751
4.7k
R711
1k
CN751
2P
CN705
2P
R713
22k
D711
MTZJ-T-72-3.6B
M741
(TABLE)
R731
100
CN742
5P
IC731
RPI-576
CN731
3P
C741
0.01
CN741
3P
R735
100
R734
12k
R732
10k
C731
10
50V
R733
1k
ADDRESS SENS
Q731
DTC114ESA
TBL ADDRES
SENS SWITCH
CN702
5P
HCD-LX10000
35
35
R721
4.7k
R722
4.7k
R723
4.7k
CN703
4P
CN751
4P
RE701
ROTARY
ENCODER
E-3
E-2
E-1
C735
0.1
C736
0.1
C737
0.1
HCD-LX10000
• See page 26 for Circuit Boards Location.
JW568
JW202
R267
JR261
R266
R262
JW193
JW208
JW209
JW386
JW210
JW101
JW394
JW288
JW393
JW292
JW289
JW293
JW102
CLP07
IC560
E
C566
1
JW295
D581
E
C560
M891
DC FAN
CN580
Q582
E
JW291 Q580
C563
E
3
D583
JW294
Q584
JW412
JW284
Q585
C581
JW290
C580
R575
JW401
JW325
R182
R183 1
CN502
8
BLK
EPT560
PA
BOARD
CN600
(Page 44)
LIGHTING
BOARD
CN01
(Page 42)
HCD-LX10000
36
36
E
K
PA
BOARD
CN601
(Page 44)
JW301
JW300
JW299
JW303
JW304
JW308
JW307
JW306
JW310
R180
JW413
E
R184
R185
R187
R186
Q180
Q181
E
R181
JW316
JW315
JW317
C180
C550
C553
C551
3 1
4 6
Location
D340
D341
D342
D401
D402
D501
D502
D503
D504
D505
D550
D560
D561
D562
D581
D583
E-3
E-3
E-3
D-5
D-5
C-5
C-5
C-5
C-5
C-6
I-12
I-8
G-9
G-10
H-13
H-13
IC101
IC301
IC401
IC402
IC550
IC560
IC561
IC562
D-9
H-5
C-4
B-5
I-12
H-9
H-9
C-6
Q101
Q151
Q180
Q181
Q250
Q251
Q280
Q281
Q340
C-8
C-8
J-10
J-10
B-12
B-12
D-9
D-10
E-2
JW580
D550
C552
JW320
JW322
R263
JW194
JW198
JW197
JW196
JW195
JW185
JW253
R580
R579
1
3
C565
JW566
R389
R251
FB509
JW135
FB508
C154
C155
JW212
JW215
JW211
JW285
JW395
JW417
CN501
J
Ref. No.
C564
C181
TRANS
BOARD
CN1213
(Page 46)
C260 C261
C103
C280
R285
R154
JW172
JW173
JW174
JW228
JW227
JW239
JW238
JW237
JW240
JW241
JW244
JW243
JW245
JW246
JW247
JW421
JW276
• Semiconductor Location
CLP06
JW216
D562
JW312
I
JW203
JW206
JW226
NO011
EPT561
K
R260 R261
C150
R281
JW231
JW230
JW229
JW233
JW232
JW225
1
JW321
E
Q380
VIDEO/MD
AUDIO IN
L
JW422
D560
JW331
R
C264
JW205
JW107
JW217
JW218
JW219
JW220
JW221
Q378
JW337
JW363
JW182
JW183
C361
JW387
R392
R265
FB261 JR260
JW204
R166
C152
JW408
JW255
JW248
JW254
JW275
JW420
JW274
JW405
JW346
JW347
R286
JR034
C159
C156
C160
JW171
JW236
JW105
JW106
JW235
JW103
JW104
JW404
JW350
JW348
R397
JW356
R369
JW338
C262
JW201
R577
C561
TV
AUDIO IN
L
R282
NO503
6
R
FB263
JW287
IC561
1
J101
JW260
CLP011
JW335
JW334
JW333
JW332
R271
R269
JW282
R388
C263
JW286
D561
JW281
C386
E
C524
C522
JW126
JR029
C105
C108
C106
R104
C140
E
CLP012
NO012
JW279
JW280
3
C355
JW339
R270 FB262
R264
R268
JW567
C562
R354
Q251
R151
JW278
RED
JW419
FB260
E
Q281
R152
C157
R157
R257
R256
E
JW200
JW199
R532
JW144
C107
JR031
C113
JW137
JW147
C122
C163
JR018
JR028
JW170
JW409
JW168
JW169
JW143
JW141
JW142
JW140
JW138
JW139
JR014
JW136
R131
C131
R130
R132
JW149
JW146
R105
C162
C115
C130
C114
R153
R106
R155
R156
JW125
C567
R485
R484
JW187
JW397
JW119
JW120
JW121
JW114
JW115
JW116
JW117
JW118
JW113
JW111
JW112
JW110
C419
JW109
JW060
JW065
R487
JW066
JW067
R400
JW068
JW064 R488 D505
C405
R478
R470
C158
R253
R250
JW176
C153
JR016
JW175
JR015
Q280
R140
14
R255
R254
E
JW191
C251 Q250
CLP01
JW341
R356 R357
C102
C281
C100
42
R252
JW184
JW223
JW340
C364
JW178
JW177
JW319
JW302
JW318
L371
R393
C354
JW358
JW357
C384
R399
C380
R386
L372
1
IC101
JW190
26
JW224
JW277
FB512
CN505
JW179
JW411
21
C250
JW189
R150
JW148
JW407
JW324
JW323
R395
J
JW108
JW390
JW058
JW145
JW059
JW056
JW351
JW354
R307
JW359
R352
L370
JW343
JW342
JW326
R379
C379
Q379
E
Q377
C372
C374
JW450
R107
13
JW188
27
JW180
C104
22
C161
JW272
JW328
R390
JR021
Q371
R370 C371
JW365 Q372
E
E
E
R382
E
R384 R383
R381
JW362
R376
R372
R373
C372
R375
C370 R371 R374 C377
Q370
JW364
E
R377
T301
R378
R396 E
E
JW273
JW271
JW327
Q375 Q376
Q374
Q373
R116
JW250
JW269
FB510
C546
C534 1
2
JW222
JW270
JW329
1
CN507
C353
E
JR390
JW268
JR020
8
E
C111
BLU
JW256
JW257
JW258
JW259
JW262
JW406
JW263
JW264
JW265
JW267
JW345
JW344
JW336
E
CLP03
Q381
Q383
E
R385 R387 Q382
C385 R391
C375 C376
JR359 R351
C356
R353
JW360
JW366
C310
JW368
JW367
C359
TAPE B
HEAD
1
40
JW369
C381 C382
C383 R380
31
JW370 JR138
CN503
H
C307 C312
R308
10
R311
R355
C351
3
L302
11
IC301
3
1
R394
C301
1
JW063
R570
JW089
JW352
JW353
R336 R337
30
TAPE A
HEAD
R122
JR030
R101
NO013
JW192
CN510
JW355
C308
20
21
C378
C309
C303
R301
R304
C121
C116
JW159
JW252
1
H00
JW
JR036
C537
JW186
JW251
(FOR CHECK)
R306
C311
JW166
JW167
JW415
JW561
C538
C547
C544
JW349
C306
R309
JW373
R302
R103
R121
JW398
C523
C535
R102
C110
JR019
JW090
JW094
C391
C305
R310
JW391
JW392
E
Q544
E
C542
3
JR017
JW150 JR022
JW151
JW152
JW153
JW154
JW155
JW156
JW157
JW158
JW160
JW161
JW162
JW163
JW164
JW165
C112
E
Q151
JW131
JW130
JW129
CN581
JW095
JW096
JW097
JW091 R476
JW092
JW093 R477
E
JW403
JW128
JW414
Q545
JR009
JR010
R545
R543
Q541
E Q543
C545
JW127
FB150
C109
Q101
R133
JW133
JW132
C568
JW098
JW099
JW100
R475
JR007
E
C543
C541
C314
R339
C304
R319
R303
R501
D502
D501
D504
JW062
JW400
JW075
JW076
JW073
JW074
JW046
JW047
JW048
JW045
JW057
JW055
JW054
JW016
JW017
JW018
C411
R493
R500
R492
JW050
JW049
C416
JW051
JW052
JW053
R503
C497 JW399
D503
X401
C498
C499
JW044
R591
JW418
C540
JW087
JW085
JW086
JW313
R312
CLP02
I
E
IC562
JW134
1
JW077
R547
R417
R413
R411
R420
JW084
R297
JW081
R540
JW083
R290
JW372
JW371
G
JW015
R427
R422 R426
R424
JR467
JR003
JR465
JW385
R541
JW082
R546 R548
3
1
8
C520
FB507
C149
4
JW123
JW124
E
JW069 CLP04
JW070
JW072
JW078
Q540 R544Q542 E
R563 Q560
1
CN100
JW122
2
C539
R582
CLP05
R562
Q561
JW061
JW071
D401
D402
R463
E
E
Q505
R486
R469
R560
E
C501
R585
R586
JR012
Q504
R502
R489
R542
R293
R294
R295
R296
JW376
JW375
JW378
JW377
JW379
JW382
JW383
JW384
JW389
JW381
JW380
F
R292
R291
JW080
R406
R505
JR468
JR004
JR005
D340
R273
R274
JW079
C503
R592
R491 R490
JW088
D342
D341
JW036 R272
C502
R587
Q583
JR466
R347
R344
E
Q340
R343
E
JW043
JW042
E
JR507
R341
Q345 Q344
E
JW035
E
R349
R348
R346
R342
E
E
R345
Q342
Q341
C341
CN509
C340
R340
JW034
Q343
E
JW040
JW041
JW039
JW033
TAPE
MECHANISM
DECK
JW013
JW007
R433
C429
C464
JR002
JW037
JW032
C410
5
4
C412
100
80 81
JW038
JW402
IC401
C462
JW027
JW028
JW029
JW030
JW031
JW416
D
51
1
E3
R409
R405
R407 R404
R403
1 R401
R402
50
JW023
JW024
JW025
JW026
IC402
R412
R593
JW021
R448
JW022
R452
R451
JR001
17
C
JW410
R447
16
31 30
X402
Q501
R305
R472
R571
R418
JW019
JW020
JW012
JW374
PANEL
BOARD
CN902
(Page 40)
JW009
JW006
JW008
R439
JW004
JW003
R419
R421
9
CN506
JR035
R423
H
1
R438
R425
JW010
JW011 R530
JW452
NO507
R429
R573
R574
JW002
12
1
12
CD
BOARD
CN201
(Page 32)
A
10
1
R428
R431
R430
R529
JW001
B
JW396
MIC
BOARD
NO1101
(Page 42)
D
11
TUNER
PACK
CN402
C430
CN508
1
2
R434
R443
R442
R538 JW014
R440
R445
R432
NO402
R446
R444
R441
4
1
JW005
(FOR CHECK)
PRIMARY
BOARD
CN1200
(Page 46)
C
10
JW181
B
(FOR CHECK)
A
9
JW214
DRINER
BOARD
CN701
(Page 34)
MAIN BOARD
: Uses unleaded solder.
8
7
JW234
JW213
JW242
6
JW522
5
JR032
C521
4
C525
3
2
1
FB506
7-11. PRINTED WIRING BOARD – MAIN BOARD –
JW297
JW298
IC550
1-864-934-
11
(14)
Ref. No.
Q341
Q342
Q343
Q344
Q345
Q370
Q371
Q372
Q373
Q374
Q375
Q376
Q377
Q378
Q379
Q380
Q381
Q382
Q383
Q501
Q504
Q505
Q540
Q541
Q542
Q543
Q544
Q545
Q560
Q561
Q580
Q582
Q583
Q584
Q585
Location
E-3
E-3
E-2
E-3
E-3
I-4
I-3
I-4
I-4
I-4
I-4
I-4
I-5
I-5
I-5
J-5
H-5
H-4
H-5
B-5
B-6
C-6
E-5
E-5
E-5
E-5
F-5
F-5
C-7
C-6
H-12
H-12
D-4
H-13
H-13
HCD-LX10000
• See page 48 for Waveforms.
7-12. SCHEMATIC DIAGRAM – MAIN BOARD (1/3) –
• See page 53 for IC Pin Function Description.
Q504
DTA114EKA
B+ SWITCH
D505
1SS355
Q505
DTC124EKA
B+ SWITCH
NO402
4P
Q501
DTC124EKA
RESET
SWITCH
12
9
29
30
C412
0.1
R413
0
C430
47p
C429
47p
X402
16MHz
31
32
32
NO507
12P
R431
R432
R433
R434
R538
33
34
R438
R439
R440
R441
R442
R443
R444
R445
R446
R447
R448
4
3
2
1
7
R407 100
R406 100
5
19
18
C411 22p
C410 22p
X401 32.768kHz
R405 100
R404 100
BUS7
100
100
100
100
100
100
100
100
100
100
100
HP DET
C499 0.1
R500 10k
BUS8
94
FPU0
R591
15k
R593 2.2k
R493 4.7k
R492 330
MASTER CONTROL
MAIN
BOARD
(2/3)
(Page38)
BUS9
R592 4.7k
R490
R489
R488
R487
R486
R485
R484
100
100
100
100
100
100
100
C498
10
50V
90
89
88
87
84
R586
10k
86
85
C497
0.1
R585
10k
82
81
37
CN509
13P
C501
10
50V D401
1SS355
R400
100
100
100
100
100
10k
IC401
M30622MEP
-A77
38
39
40
41
42
43
44
45
46
47
48
R411 330k
39
40
41
42
43
44
45
46
C419
220p
R418 220
R417 10k
28
27
26
25
24
23
22
21
R430 100
R429 100
38
R428 100
R427 100
R426 100
R425 100
R424 100
R423 100
R422 100
R421 100
R420 1k
R419 100
29
30
C502
0.1
R409
10k
R505
4.7k
29
30
33
32
9
12
DRIVER
BOARD
CN701
(Page35)
C416
2200
6.3V
R403 100
R402 100
R401 100
31
34
R529
10k
R502
1k
97
R530
10k
C503
0.1
D503
1SS355
D501
1SS355
R501 D504
220 1SS355
LEVEL DETECT
R503
0
R412
100k
CN402
10P
D502
1SS355
IC402
BD4929G-TR
R272
22k
100
100
100
100
R475
R476
R477
R478
R349
3.3k
R293
47k
75
76
77
78
R452
100
R470 100
R345
3.3k
54
Q583
DTA124EKA
BUFFER
JR507
0
R463
10k
Q344
DTC114EKA-T146
CAP MOTOR
DRIVE
R292
47k
65/A5
JR465 0
66/A6
JR466 0
67/A7
JR467 0
BUS1
BUS3
D402
1SS355
R574 10k
R573 10k
R571 10k
47
R570 10k
R294 R296
4.7k 4.7k
R295
47k
R341
3.3k
BUS5
EVER +4V
R472
100
72
BUS2
Q342
2SB1132
B TRIG DRIVE
D342
1SS355
M+9V
C462
100
10V
R348
680
C341
0.0047
R342
2.2k
Q345
DTC114EKA-T146
B TRIG DRIVE
R469
100
R347
2.2k
B-TRG
BUS6
36
Q343
DTC114EKA-T146
A TRIG DRIVE
M GND
GND
C405
0.1
R343
2.2k
A-TRG
MAIN
BOARD
(3/3)
(Page39)
55
R344
680
R340
2.2k
D340
1SS355
JW522
JW
C464
0.01
Q340
2SB1132
A TRIG DRIVE
C340
0.0047
MAIN
BOARD
(3/3)
(Page39)
71
72
73
74
R291
4.7k
89
94
48
R451
100
R346
680
D341
1SS355
R273
10k
R274
47k
R297
47k
51
52
53
54
55
56
57
58
59
90
Q341
2SB1132
CAP MOTOR
DRIVE
R290
47k
70
R587 10k
51
NO401
3P
53
PRIMARY BOARD
CN1200
(Page47)
HCD-LX10000
37
37
MAIN
MAIN
BOARD
BOARD
(3/3)
(2/3)
(Page38) (Page39)
HCD-LX10000
7-13. SCHEMATIC DIAGRAM – MAIN BOARD (2/3) –
CD
BOARD
CN201
(Page33)
C538
0.1
C524 220p
C525 220p
C534
0.1
26
27
C535
3300
10V
25
5
7
FB507 0UH
FB506 0UH
23
24
FB508 0UH
C547 220p
C546 220p
21
19
18
22
C521 220p
2
28 FB509 0UH
3
C520
0.1
C522
220p
32
C537
0.1
1
FB512
0UH
BUS9
HP DET
BUS7
BUS8
MAIN
BOARD
(1/3)
(Page37)
FB510 0UH
CN505
27P
C523
220p
JR032 0
IC562
TA78033LS
Q560
RT1P137P
B+ SWITCH
+3.3V
REGULATOR
C250
10
50V
C251
10
50V
R253
10k
R254
10k
JW266
R263 0
C568
1000
6.3V
R563
2.2k
C567
0.1
R562
2.2k
R262 0
R251
10k
Q250
2SC3661 R252
33k
MUTE
R560
2.7k
R256
33k
Q251
2SC3661
MUTE
Q561
DTC114EKA
B+ SWITCH
JW560
R257
1k
R250
1k
C154
10
50V
R255
10k
C152
10
50V
IC101
M61529FP-D60G
JW260
R153
560
R154
1k
CN506
9P
88
C153
10
50V
C539
0.1
R582
0
R140 10k
C156
0.022
R152
10k
C157
0.022
C140
0.068
C158
0.033
C262 220p
R266 100k
C261 220p
R265 100k
C260 220p
R264 100k
R270 1k
FB262 0
R271 1k
FB263 0
R269 1k
FB261 0
R268 1k
FB260 0
J101
4P
JR261
0
C264 0.47
R155
47k
R156
10k
C159
1
50V
R151
2.2k
R260 0
Q151
2SC1623
SWITCH
INPUT SELECT SWITCH,
GRAPHIC EQUALIZER CONTROL,
ELECTRICAL VOLUME
R157
200
R267 100k
R261 0
R166
100
C155
10
50V
C263 220p
C160
0.01
C161
C162 C163
10 0.27
0.27
50V
R122
10k
82
C122
220p
TUNER PACK
87
86
85
84
R532
0
CN100
4P
FB150
0
MIC
BOARD
NO1101
(Page43)
C103
10
50V
R150
100
C149
0.1
R132
1M
C121
220p
81
M GND
GND
C113 0.27
C111
10
50V
R106
10k
R103
560
C109
1
50V
R105
47k
C281
10
50V
R281 R285
10k 10k
R107
220
C105
10
50V
C104
10
50V
NO011
R131 C130
10
2.2k
50V
E
C115
0.1
R IN
M+7V
NO013
L IN
C116
220
10V
GND
R133
100k
NO012
R286
33k
REC L
TC MUTE
TC R
CD MUTE
REC R
A+9V
R282
33k
R116
100
R130
2.2k
Q281
2SC3661
MUTE
TC L
Q280
2SC3661
MUTE
C131
0.47
50V
Q101
2SC1623
SWITCH
DBFB FB
C280
10
50V
C110
0.01
R121
10k
C114 10 35V
MAIN
BOARD
(3/3)
(Page39)
R102
10k
R101
2.2k
C108
0.033
SPEANA
MAIN
BOARD
(1/3)
(Page37)
C107 0.022
C106
C102
10
50V
C112 0.27
C100
100
10V
0.022
C150
10
50V
R104
1k
MAIN
BOARD
(3/3)
(Page39)
HCD-LX10000
38
38
A+9V
SPEANA OUT
LIGHTING
BOARD
CN01
(Page43)
HCD-LX10000
• See page 48 for Waveforms.
7-14. SCHEMATIC DIAGRAM – MAIN BOARD (3/3) –
CN508
17P
C181
4.7
50V
JW503
D562
10EDB40
R185
1k
D561
10EDB40
C543
1
50V
C540
1
50V
R543
68k
Q540
DTA124EKA
CD MUTE DRIVE
R541
15k
C542
1
50V
R544
15k
C311
10
50V
R303
10k
C314
0.0022
CN510
3P
C301
0.012
100V
Q542
DTA124EKA
TC MUTE DRIVE
C304
R302 10 50V
4.7k C303
0.1
R301
3.3k
R337
10k
R304
2.2k
66/A6
DECK A/B SELECT
PB/REC EQUALIZER AMP
+9V
REGULATOR
C307
10 50V C312
10
50V
C562
100
16V
R390
10k
IC560
BA09T
67/A7
+9V
REGULATOR
R381
2.2k
R373
4.7k
L370
27mH
C378
120p
R380
8.2k
C383
330p
R369
2.2k
C354
10 16V
L302
100uH
IC550
RT8H015C-T112-1
C552
2.2
50V
R354
2.2k
R355
47k
C553
1000
25V
R357
10k
C550
100
16V
C386
0.022
R391
10k
R389
22k
R397
2.2k
C361
10
50V
C385
0.022
C551
0.1
EPT560
L372
100uH
R395
47k
R378
10k
Q370
2SD596
BIAS OSC
T301
C374
47
35V
Q378
RT1P137P-TP-1
SWITCH
C377
0.01
C379
0.0068
R379
10
R394
4.7k
CN501
13P
-VL
-VL
R377
47
R386
33
GND
C373
0.001
PROTECTOR CCT
D550
1SS355
R393
2.2k
56
C566
4700
25V
C356
2.2
50V
C355
1
50V
R356
6.8k
C564
0.1
77
76
C384
330p
C353
0.1
R353
10k
C364
0.0022
R392
10k
R351
3.3k
R352
4.7k
Q381
DTC114EKA
BUFFER
R388
6.8k
C563
470
10V
58
M GND
C371
0.0047
C380
120p
R374
4.7k
R370
3.3k
C351
0.012
100V
R399
10k
Q379
DTC114EKA
SWITCH DRIVE
R309
4.7k
59
C391
100
16V
57
R372
10k
R371
4.7k
R396
10k
C565
0.1
C308
470
10V
R311 0
R312 100
R382
2.2k
L371
27mH
C580
0.1
70
R384
2.2k
R375
10k
C372
0.001
R310 100
BUS6
R376
4.7k
L IN
IC561
TA7809LS
C359
47
35V
Q371
2SC3661
SWITCH
JW580
R548
470k
R308 100
Q383
DTC114EKA
SWITCH DRIVE
Q377
2SA1235TP
SWITCH DRIVE
Q372
2SC3661
SWITCH
Q582
2SC1623
D583
UDZ6.8B
65/A5
R383 2.2k
D581
UDZ6.2B
Q544
DTA124EKA
LINE MUTE
DRIVE
IC301
HA12237F
R307
1M
C310
10
50V
Q382
DTA114EKA
SWITCH DRIVE
R387
2.2k
Q373
2SC3661
SWITCH
R580
10k
R577
100k
72
R180
10k
75
78
52
R385
2.2k
Q374
2SC3661
SWITCH
R579
10k
Q584
DTC114EKA
Q580
2SC1623
C376
680p
C370
0.01
100V
R181
10k
R306
22k
Q376
2SC3661
SWITCH
TAPE B
HEAD
Q180
2SC3661
MUTE
C581
0.1
R305
47k
C306
2.2
50V
C305
1
50V
C381
1200p
Q375
2SC3661
SWITCH
Q585
2SD2525
R339
22k
TAPE A
HEAD
C375
680p
R184
1k
R575
1k
C544
1
50V
R547
15k
R545
470k
C309
47
35V
CN507
8P
R182
47k
BUS5
R336
6.8k
R319
2.2k
C382
1200p
R183
47k
C180
4.7
50V
R542
470k
C560
0.01
CN503
3P
R186
10k
C545
1
50V
D560
D3SBA20-4101
C561
0.01
Q545
DTC114EKA
BUFFER
R546 68k
R540 68k
C541
1
50V
NO503
6P
65/A5
37
Q543
DTC114EKA
MUTE DRIVE
Q541
DTC114EKA
MUTE DRIVE
JW382
R187
10k
Q181
2SC3661
MUTE
97
TRANS
BOARD
CN213
(Page47)
R IN
DBFB FB
BUS1
EVER +4V
BUS3
BUS2
M+9V
71
29
30
4
73
74
72
PANEL
BOARD
CN902
(Page41)
REC R
M+7V
TC MUTE
CD MUTE
A+9V
TC R
TC L
REC L
SPEANA
MAIN
BOARD
(2/3)
(Page38)
CN502
8P
Q380
DTC114EKA
SWITCH
MAIN
BOARD
(1/3)
(Page37)
MAIN
BOARD
(1/3)
(Page37)
MAIN
BOARD
(2/3)
(Page39)
HCD-LX10000
39
39
PA
BOARD
CN600
(Page45)
PA
BOARD
CN601
(Page45)
CN580
3P
MAIN
BOARD
(1/3)
(Page37)
HCD-LX10000
• See page 26 for Circuit Boards Location.
4
: Uses unleaded solder.
5
6
–
M
D930
S932
JW910
JW909
JW908
JW907
D905
JW972
JW973
JW900
JW906
JW902
JW911
JW970
JW976
JW952
JW969
JW974
JW968
JW967
R961
JW1145
R1180
D910
R933
R943
TAPE A/B
R1167
D916
R973
R989
R988
R987
S930
JW957
GROOVE
JW960
S920
CD
Ref. No.
S919
TUNER BAND
R967
S918
TAPE A/B
Q909
E
R966
S931
S927
ENTER
R964
AMP MENU
R1198
R1197
D918
R990
JW1144
R993
D925
R994
R995
R996
JW1117
SOUND FLASH
DIRECTION
TUNER MEMORY
JW977
JR917
JR916
JR913
R960
JW958
JW959
JW961
JW962
JW964
JW963
JW965
JW1110
8
R959
D926
S911
E
Q916
R991
R992
R974
R1195
R1194
TV
R965
Q910
E
S910
VIDEO/MD
VIDEO/MD
1-864-912-
G
H
MAIN
BOARD
CN508
(Page 36)
L
HCD-LX10000
40
40
• Semiconductor
Location
TV D917
JW966
S970
VOLUME
D909
R972 Q915 E
R984
R985
R986
JW955
R963
S928
JW953
R968
R914
R915
JW956
R962
R980
D908
TUNER
BAND
JW975
ILLUMINATION
1
JR911
R944
JW954
C917
S929
SURR SPEAKER
MODE
R975
C981
C982
C983
C972
C973
C928
C927
C929
C930
C931
C932
C933
C934
C935
C936
C937
C938
JW971
S900
DISPLAY
E
Q907
E
Q908
E
R969
R981
R982
R983
C970
E
R911 R999
D907
C918
CNS902
JW980
JW979
JW978
D906
R1188
JW1112
D903
CD
R977
Q906
Q905
R910
Q914
S903
t
C922
E
R978
R919
R918
R917
JW924
JW926
JW925
JW927
C924
C925
C980
JW923
JW922
JW921
JW920
JW919
JW918
JW917
JW916
JW915
JW914
JW913
JW912
JW948
R902
R907
JW986
JW991
JW990
JW989
JW988
JW987
R958
JW1160
JW1113
JW1114
JW1115
JW1116
JW1118
2
1
3 R970
C907
E
C971
CLP912
R971
ALBUM
ALBUM
–
M
JW1119
JW1120
JW1122
t
JW1123
D914
M
+
JW1146
S902
EQ BAND
X901
Q904
C939
C919
FB901
t
R939
R1161
E
t
JW1126
R1177
Q920
M
+
R1178
R1176
>
R1147
R1148
JW1131
S917
JW1151
JW1124
JW1147
–
D904
JW929
JW1148
S904
R905
R906
MP3 BOOSTER
R1175
REC
PAUSE/
START
D929
C906
R1160
TUNING
C902
C901
C909
JW903
JW1125
t
t
JW1127
TUNING
CN902
R1163
>
+
S916
E
C910
D913
R1162
F
S901
C961
JW1153
JW1152
R912
80 81 R922
JW1149
JW904
CD SYNC
JW1128
JW1129
JW994
C916
C908
R956
S912
IC903
3 2 1
100
C966
E
1
Q919
JW1138
JR918
1
IC902
S925
D902
JW951
E Q901
E
R1183 R1189
Q902
50
E
Q917
Q903
R908
R941
R940
R942
E
C923
JR914
51
C905
E Q900
D927
D901
JW950
R903 R904
JW995
JW993
x
JW1130
CD-SW
BOARD
NO1150
(Page 42)
3
JW1162
M
JW996
JW1161
S915
NO903
R948
R951
R954
70
C926
JW949
JW935
JW936
JW937
JW938
JW939
JW940
JW941
JW942
JW943
JW944
JW945
JW946
JW947
D912
x
R1166
10
R946
R1142
R1141
R945 C945
JW1154
1
11
JW901
31 30
JW905
JR922
C947
C950
C952
C954
C956
C958
IC904
S914
C903 R900
JR910
JR909
R901
JR912
X
JW1132
D
20
D928
X
C
R952
R950
R953
11
C979
C978
C977
C941
R1165
JW930
JW931
JW932
JW933
JW934
R949
C959
C955
JW1134
R947
JR921 JR915
C942
C957
JW1135
R1164
JW1133
JW1155
JW1137
C900
C953
C951
C949
C948
C946
R1135
D915
R1137
JW1136
B
D911
JW1156
R957
R1179
Q918
R1136
JW928
FL901
FLUORESCENT
INDICATOR TUBE
C904
R997
10
64
C944
E
9
65
7
1
A
S913
8
7
R909
R1187
R1186
R920
PANEL BOARD
6
JW985
JW984
JW983
JW982
JW981
3
2
1
JW997
JW998
JW999
JW1150
7-15. PRINTED WIRING BOARD – PANEL BOARD –
JOG
BOARD
CNS903
(Page 42)
11
(11)
Location
D901
D902
D903
D904
D905
D906
D907
D908
D909
D910
D911
D912
D913
D914
D915
D916
D917
D918
D925
D926
D927
D928
D929
D930
B-10
B-10
D-7
D-6
B-9
C-10
C-10
D-10
D-10
D-10
B-3
C-3
D-3
E-3
B-3
E-10
E-10
F-10
F-10
F-10
B-10
C-3
E-3
F-3
IC902
IC903
IC904
C-7
B-10
C-4
Q900
Q901
Q902
Q903
Q904
Q905
Q906
Q907
Q908
Q909
Q910
Q914
Q915
Q916
Q917
Q918
Q919
Q920
A-10
C-8
C-8
B-10
B-10
C-10
C-11
C-11
C-10
E-10
F-10
C-8
D-10
F-10
A-11
B-2
D-3
E-3
HCD-LX10000
• See page 48 for IC Block Diagrams.
7-16. SCHEMATIC DIAGRAM – PANEL BOARD –
• See page 48 for Waveforms.
• See page 55 for IC Pin Function Description.
R908
100
D901
1SS355WTE-17
Q900
DTA114EKA
LED DRIVE
FL901
FLUORESCENT INDICATOR TUBE
R1183
82
IC903
RPM7240-H8
Q903
DTA114EKA
LED DRIVE
100p
100p
100p
100p
100p
100p
100p
100p
100p
100p
100p
100p
100p
470p
100p
100p
100p
100p
100p
100p
100p
100p
100p
100p
R1189
22
Q917
DTC114EKA
LED DRIVE
REMOTE CONTROL
RECEIVER
C939
0.001
C977
C978
C979
C980
C924
C925
C926
C927
C928
C929
C930
C931
C932
C933
C934
C935
C936
C937
C938
C981
C982
C983
C972
C973
JW900
D927
SELU5620S-STP15
R944
47
Q914
DTC143TKA
BUFFER
93
Q901
DTC143TKA
BUFFER
92
91
90
89
88
87
86
85
7
6
5
4
3
2
1
100
99
98
97
96
47
46
45
44
43
41
40
39
38
37
36
35
34
33
32
31
30
29
28
27
26
25
24
22
21
20
19
18
17
16
15
14
13
12
10
9
8
I/
D902
SELU5420E-STP15
C922
10
50V
C944
10
50V
C923
0.01
S900
DISPLAY
JR914
0
10
9
8
7
6
5
4
3
2
1
Q902
DTC143TKA
BUFFER
22
21
20
19
18
17
16
15
14
13
12
30
29
28
27
26
25
24
94
95
S925
R1167
270
I/
R917
100k
43
44
45
46
47
D909
SELU5420E-STP15
D908
SELU5620S-STP15
R968
15k
Q915
DTC114EKA
LED DRIVE
R967
10k
R941
100
R940
10k
D905
UDZ-TE-17-6.8B
R1197
1k
R990
680
R1198
1k
S932
ENTER
R992
680
R974
680
Q910
DTC114EKA
LED DRIVE
R991
680
55
R1194
1k
78
10k
10k
4.7k
10k
100
0.1
220p
Q906
DTC114EKA
BUFFER
R996
680
R994
680
Q916
DTC114EKA
LED DRIVE
C955 C953 C951
1
1
1
C957
1
71
67
68
69
70
C949 C942
1
10
50V
C941
10
50V
R956
2.7k
C966
0.1
R978
470
R975
470
R995
680
R993
680
R1195
1k
C961
0.1
Q905
2SB1115A-YQ
SWITCH
VIDEO/MD
R959
680
JR915
100
79
80
68
69
70
71
72
73
D926
SELU5420E-STP15
TV
R958
470
D904
10EDB40
R953 1k
D925
SELU5620S-STP15
MAIN
BOARD
(3/3)
CN508
(Page39)
R942
100
R999
0
Q904
2SB1115A-YQ
SWITCH
D918
SELU5420E-STP15
D917
SELU5620S-STP15
R960
1k
S931
SOUND
FLASH
D903
10EDB40
JW905
R961
1.5k
S930
GROOVE
C919
0.01
R909
R1187
R1186
R920
R912
C916
C908
R973
680
R988
680
Q909
DTC114EKA
LED DRIVE
54
220p
220p
220p
100
100
0.1
R962
1.5k
R989
680
R987
680
R933
1k
C909
C901
C902
R903
R904
C910
R943
1k
74
75
76
77
58
59
60
C905
0.1
TAPE A/B
R963
2.2k
NO903
S904
REC PAUSE/START
X901
4MHz
64
C903
0.1
D916
SELU5420E-STP15
D910
SELU5620S-STP15
R964
3.3k
S929
SURR SPEAKER
MODE
R1178
1.5k
R922
1M
R900
10k
S927
AMP MENU
S928
ILLUMINATION
S903
DIRECTION/
TUNER MEMORY
C904
0.1
R965
4.7k
S910
VIDEO/MD
C918
470
6.3V
CN902
17P
77
61
60
R1177
1k
C917
0.1
65
66
67
S911
TV
53
R901
10k
R972
680
R985
680
R905 15k
R906 15k
R907 15k
R966
6.8k
R986
680
R984
680
R915
1k
R914
1k
61
S918
TAPE A/B
C970
470
6.3V
S902
EQ BAND
FB901
0
52 R902 10k
53
54
55
56
57
S919
TUNER/BAND
TUNER/
BAND
C971
470
6.3V
R947 1k
C900
4.7
50V
52
S920
CD
CD-SW
BOARD
NO1150
(Page43)
R969
680
R982
680
R1176
680
R950 1k
R983
680
R981
680
R911
1k
IC902
MB90M407PF-G-144E1
R1180
270
S901
MP3 BOOSTER
R949 1k
CD
Q908
DTC114EKA
LED DRIVE
66
73
31
32
33
34
35
36
37
38
39
40
41
D907
SELU5420E-STP15
D906
SELU5620S-STP15
R910
1k
64
R1175
470
100
99
98
97
96
95
94
93
92
91
90
89
88
87
86
85
R952 1k
R918
100k
R919
100k
C946
470p
C948
470p
R980
1k
R977
1k
CLP912
Q907
DTC114EKA
BUFFER
IC904
NJM2760V-TE2
80
C907
0.001
R1164
2.2k
R1165
3.3k
R1166
4.7k
R1160 R1161
6.8k
10k
S917
+
-
R957
1k
R1179
1k
R997
680
R1137
680
R1135
680
R1141
1k
R1142
1k
D928
SELU5620S-STP15
R1147
1k
R1148
1k
D929
SELU5620S-STP15
R1136
680
Q918
DTC114EKA
LED DRIVE
-
Q919
DTC114EKA
LED DRIVE
S912
CD SYNC
D930
SELU5620S-STP15
CNS902
8P
-
Q920
DTC114EKA
LED DRIVE
R970
6.8k
S970
VOLUME
JOG BOARD
CNS903
(Page43)
HCD-LX10000
41
41
S913
S914
S915
ALBUM
C947
1
S916
TUNING
+
C945 R945
33k
1
C950 0.0047
+
R1163
1.5k
C954 0.022
C906
0.001
R1162
6.8k
C952 0.0047
76
74
57
58
59
75
R1188
1k
+
R939
1k
R971
1k
C956 0.022
D914
SELU5620S-STP15
C959 0.047
D913
SELU5620S-STP15
D912
SELU5620S-STP15
C958 0.047
D915
SELU5420E-STP15
D911
SELU5620S-STP15
78
79
56
72
65
BPF
R954
10k
R951
5.6k
R948
6.8k
JR912
0
R946
56k
HCD-LX10000
7-17. PRINTED WIRING BOARDS – CD-SW, JOG, MIC, LIGHTING BOARDS – • See page 26 for Circuit Boards Location.
3
2
1
4
5
: Uses unleaded solder.
6
8
7
9
10
11
12
CD-SW BOARD
A
NO1150
3
M
1
PANEL
BOARD
NO903
(Page 40)
B
R1172
R1174
R1169
S1160
Z OPEN/CLOSE
EX-CHANGE/
DISC SKIP
S1156
DISC 1
1-864-914-
11
(11)
J01
D-LIGHT
SYNC OUT
LIGHTING BOARD
5
1
R05
D924
VOL 1
D03
E
R03
D
CNS903
8
JW01
D02
Q01
D01
R01
C06
CN01
1
3
CLP01
E
E
J1100
J1101
MIC1
MIC2
J1103
PHONES
MAIN
BOARD
(Page 36)
2
1
C1150
R1156
S1161
OPERATION
DIAL
VOL 6
D922
VOL 5
Q911
E
JR904
PANEL
BOARD
CNS902
(Page 40)
BLU
RED
BLK
1-869-828-
L
11
(11)
3
D923
R1158
R1144
Q912
2
JOG BOARD
R1145
E
R1146
1
R1190
D919
VOL 2
JR905
R1139
R1192
R1191
3
R1157
JW02
4
R1138
C07
R1159
B01
R1171
S1157
DISC 2
S1158
DISC 3
R1140
C
S1159
R1173
E
Q913
D921
VOL 4
D920
VOL 3
1-864-915-
11
(11)
F
C1142
N
42
MAIN
BOARD
CN100
(Page 36)
R1114
C1118
R1124
C1130
9
IC1101
R1116
1
C1125
C1127
C1124
R1121
R1119
C1119
R1117
R1118
C1117
8
C1129
C1123
D1102
C1121
R1120
JR1105
D
R1126
16
R1115
1 CLP1100
R1125
42
JR1104
R1110
9
HCD-LX10000
JR1108
R1102
R1132
C1115
R1113
C1120
R1123
C1128
EPT1103
C1106
C1126
R1122
JW1107
CLP1101
JR1113
R1111
NO1101
H
C1101
C1108
JR1114 C1122
5
IC1100 8
1
PA
BOARD
NO601
(Page 44)
C1111
JR1101
C1131
3
R1105
C1109
R1109
C1110
JR1102
C1114
JW1104
JW1101
1
C1104 4
JR1103
R1103
C1105
C1139
R1104
C1113
JW1103
C1102
JR1106
R1108
C1112
C1133
G
R1101
C1103
R1106
D1100
D1101
EPT1104
CN1102
C1116
• Semiconductor
Location
Ref. No.
C1100
JW1108
R1100
JW1109
FB1100
RV1101
ECHO LEVEL
JW1105
FB1101
RV1100
MIC LEVEL
R1107
MIC BOARD
1-864-913-
11
(11)
Location
D01
D02
D03
D919
D920
D921
D922
D923
D924
D1100
D1101
D1102
D-2
D-2
D-2
E-11
E-11
E-12
D-12
D-11
D-10
G-6
G-6
G-7
IC1100
IC1101
H-6
H-8
Q01
Q911
Q912
Q913
D-2
D-11
E-12
E-11
HCD-LX10000
7-18. SCHEMATIC DIAGRAM – CD-SW, JOG, MIC, LIGHTING BOARDS –
CN01
3P
R01 100
-
D01
D02
1SS355W 1SS355W
MAIN
BOARD
(2/3)
(Page 38)
C06
0.01
J01
D-LIGHT
SYNC OUT
R05
Q01
2SC5053 0
+4V REG
R03
680
C1100 R1101
1k
0.01
D03
UDZ4.7B
C07
0.1
IC1100(2/2)
NJM4565M-D
IC1100(1/2)
NJM4565M-D
C1102
2.2
50V
C1103
47p
C1106
2.2
50V
J1100
R1100
10k
B01
C1104
0.001
R1104
100k
R1107
100
R1106
47k
C1108
2.2
50V
RV1100
50k
R1103
1k
R1171
1.5k
R1172
1.5k
R1173
1k
R1169
470
R1174
680
R1105
1k
R1102
10k
NO1150
3P
S1157
S1158
PANEL
BOARD
NO903
(Page41)
S1160
S1159
OPEN/CLOSE
C1123
0.068
C1121
47
16V
C1124
1
50V
C1118
0.0068
C1120
0.068
D922
SELU5223C-STP15
RED
D921
SELU5223C-STP15
RED
D919
SELU5223C-STP15
RED
JR905
0
R1138
820
R1139
820
R1190
100
R1140
820
R1191
100
R1144
820
R1146
820
Q913
DTC114EKA
LED DRIVE
Q912
DTC114EKA
LED DRIVE
C1119
0.0015
C1116
0.0022
C1131
220
10V
C1112
10
50V
R1125
2.2k
C1111
47p
R1126
2.2k
C1130
0.015
R1121
15k
R1159
820
MAIN
BOARD
(2/3)
CN100
(Page38)
NO1101
4P
C1133
0.47
JW1101
R1192
100
Q911
DTC114EKA
LED DRIVE
HCD-LX10000
43
C1125
0.0015
R1122
15k
C1126
0.0068
R1156
1k
S1161
R1114
15k
R1124
47k
R1158
820
R1157
820
C1117
1
50V
RV1101
50k
R1132
0
IC1101
M65850FP-E1
D924
SELU5223C-STP15
RED
D923
SELU5223C-STP15
RED
R1145
820
R1115
330
C1115
2.2
50V
R1118
15k
R1119
15k
JR904
0
C1150
0.001
R1117
15k
R1111
100k
C1113
10 50V
R1116
330
CNS903
8P
D920
SELU5223C-STP15
RED
C1122
47
16V
C1114
0.22
50V
C1110
150p
R1113
15k
D1102
DT5.1B
R1120
120k
PANEL
BOARD
CNS902
(Page41)
R1108
10k
C1105
470p
J1101
S1156
R1109
150k
C1139
1
50V
C1101
0.01
R1110
100
C1109
47p
43
FB1100
0
FB1101
0
D1101
1SS355WTE-17
C1127
0.068
R1123
15k
D1100
1SS355WTE-17
C1129
0.22
50V
C1142
0
C1128
0.22
50V
EPT1103
EPT1104
CN1102
3P
PA
BOARD
NO601
(Page45)
J1103
HCD-LX10000
• See page 26 for Circuit Boards Location.
: Uses unleaded solder.
C649
E
R665
JWH600
R645
F
JW669
R666
C654
D624
R630
R628
R627
R626
R632
Q644
JW675
JW674
C683
JW600
JW602
E
JW691
Ref. No.
R629
1-864-930-
1
JW681
• Semiconductor
Location
R631
E
Q628
C604
JW673
NO600
PL600
R691
JW677
EP690
C605
R633
E
R644
E
L
TH630
TH629
JW614
JW613
R653
JW695
JW694
JW603
JW672
Q647
TM601
R
Q666
E
L
RY665
R650
R600
R652
JW628
JW627
JW626
JW696
R603
R651
JWH603
C601
C652
R617
R695
R696
JW670
JW671
C693
SURR SPEAKER
JWH602
R601
C651
JW693
C602
R602
D611 D612
JW668
R647
R648
R681
JW676
D655
R654
R655
C691
C692
R646
R
FRONT SPEAKER
D646
JW606
JW605
JW604
JW616
C650
C600
R668
RY646
D665
JW623
JW622
JW621
JW624
C616
C666
C617
JW625
C610
R673 R623
R604
R605
JW632
JW635
JW629
JW630
JW620
C609
R612
R615
JW647
JW649
JW645
JW648
JW650
D654
JW607
Q629
–
R661
R660
R667
E
JW688
JW608
C655
R616
IC600
C682
C681
JWH601
C619
JW667
D660
R649
TM600
R619
C667
12
JR600
D620
R692
D609
R693
R608
R698
R609
R672
11
R625
R624
R674
+
E
JW617
D670
JW618
E Q606 Q604 R671
JW619
R621
R607
R670
JR603
R606
R620
R669
E
E
E
Q668
Q618
Q610
C636
JW641
D658
–
8
CN601
R622
C637
C618
1
10
Q630
Q648
R641
R694
Q640
C635 C608
JW639
R639
R685
+
R642
R662
R634
R697
JW644
JW651
JW699
JW700
D656
D661
Q634
E
JW663
C660
JW665
E
R658
JW662
JW664
C648
E
JW638
E
R640
R610
E
Q682
C658
R676
R677
EP660
PL601
JW643
JW642
JW653
JW652
JW654
C656
JW601
R657
R656
JW660
JW661
D
JW637
R636
JW698
JW659
C
1
Q641
JW658
R683
3
NO601
R678
78
C6
76
C6
JW657
B
JW682
JW683
R663
R637
R643
JW680
JW655
JW656
PL602
JW684
JW679
R682
JW636
13
R635
CN600
JW678
JW640 R638
1
JW631 R611
PA BOARD
9
MAIN
BOARD
CN502
(Page 36)
K
R614
N
MIC
BOARD
CN1102
(Page 42)
JW634
JW633
MAIN
BOARD
CN501
(Page 36)
8
7
JW692
J
A
6
R618
5
R613
4
C634
3
2
1
JW646
7-19. PRINTED WIRING BOARD – PA BOARD –
11
(11)
Location
D609
D611
D612
D620
D624
D646
D654
D655
D656
D658
D660
D661
D665
D670
A-6
E-7
E-7
B-7
E-9
B-10
B-9
B-10
E-4
E-5
E-2
E-2
C-10
B-7
IC600
D-8
Q604
Q606
Q610
Q618
Q628
Q629
Q630
Q634
Q640
Q641
Q644
Q647
Q648
Q666
Q668
Q682
B-7
B-6
B-7
B-7
E-9
D-10
E-9
B-6
B-6
B-5
F-1
F-1
E-2
E-1
B-7
A-6
7
G
P
TRANS
BOARD
CN1212
(Page 46)
HCD-LX10000
44
44
HCD-LX10000
7-20. SCHEMATIC DIAGRAM – PA BOARD –
IC600
STK412-150
POWER AMP
VL(AC)
GND
GND
GND
VH(AC)
VH(AC)
NO600
7P
VL(AC)
TRANS
BOARD
CN1212
(Page47)
Q618
2SC3722K-E
OVERLOAD DET
R618
0.1
5W
D656
D5SBA20
R656
220k
R657
220k
C656
3300
100V
R668
0.1
5W
R602
470
R612
100
C618
10
100V
R613
3.3k
1W
C602
100
10V
R653
47k
R620
33k
R670
33k
R671
100k
D620
1SS355
R621
100k
D670
1SS355
C666
0.068
C654
220p
D611
UDZ-TE-17-18B
R619
1k
C652
100
10V
R652
470
Q668
2SC3722K-E
OVERLOAD DET
R669
1k
C693 C683
0.1
0.1
C605
0.1
R614
3.3k
1W
C676
3300
100V
C616
0.068
R603
47k
C604
220p
D612
UDZ-TE17-18B
R660
22k
D660
1SS355
R661
22k
D661
1SS355
R678
100k
R696
100k
R617
100k
R622
10
1/2W
R616
1
R672
10
1/2W
C692
0.068
C682
0.068
C691
0.068
C681
0.068
R691
10
1/2W
R681
10
1/2W
R
SURR SPEAKER
JW691
JW677
C658
3300
50V
R698
100k
R608
100k
Q610
2SC3722K-E
D609
1SS355
R609
68k
JW681
TM600
R694
68k
JW676
R624
22k
C608
22
50V
R611
33k
R623
68k
R674
22k
C601
0.0022
C651
0.0022
R601
47k
R651
47k
R600
1k
Q604,606,610
STANBY SWITCH
R606
47k
R655
47k
R654
47k
RY646
R610
68k
R693
100k
R607
2.2k
D655
1SS355
C609
22
100V
C678
3300
50V
R
R673
56k
C637
4.7
100V
Q640
2SC3661
HEADPHONE
MUTING
R650
1k
Q634
DTA124EKA-T146
MUTING
CONTROL SWITCH
Q604
2SC3722K-E
R604
10k
R692
47k
C600
4.7
50V
R605
10k
C660
100000p
C635
100
25V
R697
2.2k
R635
10k
C634
100
25V
R634
2.2k
C650
4.7
50V
R637
680
2W
R640
1k
Q641
2SC3661
HEADPHONE
MUTING
R682
1k
Q682
2SC1623-L5L6
MUTING
CONTROL SWITCH
R638
100k
R642
150
R646
82
1/2W
R639
100k
C636 R636
4.7 680
100V 2W
R685
10k
C648
100
10V
R633
56k
PREGND
POWER GND
POWER GND
R628
22k
R630
100k
CN601
8P
Q630
2SC1623-L5L6
TEMPERATURE
DETECT SWITCH
R627
1k
R629
5.6k
TH629
MAIN BOARD
(3/3)
CN502
(Page39)
R626
56k
R632
100k
NO601
3P
Q629
2SC1623-L5L6
FAN MOTOR
ON SWITCH
TH630
MIC
BOARD
CN1102
(Page43)
Q628
2SC1623-L5L6
TEMPERATURE
DETECT SWITCH
HCD-LX10000
45
45
Q666
2SC1623-L5L6
SPEAKER PROTECT
RELAY DRIVE
R666
4.7k
R647
4.7k
R667
10k
Q647
2SC1623-L5L6
FRONT SPEAKER
RELAY DRIVE
D624
1SS355
R631
100k
D665
1SS355TE
R648
4.7k
R645
10k
EP660
MAIN BOARD
(3/3)
CN501
(Page39)
L
Q644
2SC1623-L5L6
FRONT SPEAKER
RELAY DRIVE
R644
2.2k
R643
150
FRONT SPEAKER
RY665
D646
1SS355
R665
82
1/2W
R641
1k
R683
4.7k
R625
2.7k
CN600
13P
L
D654
1SS355
C655
10
50V
C610
22
100V
Q606
2SA1207
TM601
R695
100k
R615
100
R658
100k
EP690
C617
0.068
C619
10 100V
D658
D5SBA20
C667
0.068
R662 150
R677
220k
R663 150
R676
220k
Q648
C649
2SC1623-L5L6
10
OVER LOAD
50V
DETECT SWITCH
R649
22k
HCD-LX10000
7-21. PRINTED WIRING BOARDS – TRANS, PRIMARY BOARDS –
3
2
1
• See page 26 for Circuit Boards Location.
4
5
6
: Uses unleaded solder.
8
7
9
10
T1200
POWER TRANSFORMER
TRANS BOARS
F1241
A
FH1242
JW1202
JW1201
1
JW1223
PL1213
FH1261
FH1262
F1271
FH1272
JW1230
FH1271
NO1211
F1281
2
FH1282
FH1281
D1292
6
C1263
C1262
D1264
JW1211
JW1210
1
MAIN
BOARD
NO503
(Page 36)
PL1212
PL1211
REPLACEABLE:
* NOT
BUILT IN TRANSFORMER
PRIMARY BOARD
C1292
E
R1263
R1262
R1292
Q1264
R1264
*
CN1213
I
JW1216
1
D
PA
BOARD
NO600
(Page 44)
F1261
JW1221
C
CN1212
JW1222
JW1220
B
P
FH1251
FH1252
JW1208
JW1209
JW1233
7
F1251
JW1206
JW1207
R1233
FH1241
1-864-931-
11
(11)
EP1203
E
1
RY1200
AC IN
CN1202
JW1204
MAIN
BOARD
NO401
(Page 36)
C1204
PL1202
F
R1200
3
Q1200
E
CN1200
C
C1202
D1200
R1201
C1206
NO1201
2
1
JR1202
L1201
C1201
NO1203
PL1201
G
2
JW1214
1
CN1204
JW1213
JW1215
2
• Semiconductor
Location
1
POWER
SWITCHING
H
PL1200
Ref. No.
1-864-932-
11
(11)
HCD-LX10000
46
46
Location
D1200
D1264
D1292
E-3
D-8
C-7
Q1200
Q1264
F-3
D-8
HCD-LX10000
7-22. SCHEMATIC DIAGRAM – TRANS, PRIMARY BOARDS –
F1241
T8AL/125V
F1251
T8AL/125V
CN1212
7P
F1261
T8AL/125V
F1271
T8AL/125V
PA
BOARD
NO600
(Page45)
T1200
POWER
TRANSFORMER
CN1204
2P
NO1211
JW1204
C1292
100
63V
*
F1281
T3.15AL/125V
JW1213
CN1213
6P
R1292
0.68
R1233
3.3M
1/2W
D1292
10EDB40
JW1214
JW1233
JW1292
JW1293
*
MAIN
BOARD
(3/3)
NO503
(Page39)
VF(2)
VF(1)
-VG
JW1215
JW1211
C1263
100
50V
D1264
HZU36BTRF
NO1203
2P
RY1200
NOT REPLACEABLE:
BUILT IN TRANSFORMER
Q1200
2SC1623-L5L6
RELAY DRIVE
C1262
10
50V
R1200
4.7k
D1200
1SS355TE
CN1202
2P
AC IN
R1264
1k
R1263
8.2k
R1201
100k
R1262
8.2k
C1201
0.1
C1206
1000
6.3V
Q1264
2SB1565E
–35V REG
CN1200
3P
MAIN
BOARD
(1/3)
NO401
(Page37)
HCD-LX10000
47
47
L1201
18uH
JR1202
0
C1202
0.1
C1204
0.1
EP1203
NO1201
2P
HCD-LX10000
• IC Block Diagram
• WAVEFORMS
– CD BOARD –
– MAIN BOARD –
1 IC101 wa TEI
– PANEL BOARD –
1 IC401 qa XC-OUT
– DRIVER Board –
– PANEL Board –
IC701, 712 BA6956AN
IC904 NJM2760V-TE2
1 IC902 is X OUT
TSD
2.7 Vp-p
0.15 Vp-p
4 MHz
2
3
4
5
6
7
8
9
OUT1
VM
VCC
FIN
GND
RIN
2 IC401 qd X-OUT
1
RNF
BUF1OUT 3
1V/DIV, 0.2 µsec/DIV
OUT2
2 IC101 wd FEI
BPF
CONTROL LOGIC
VREF
1V/DIV, 10 µsec/DIV
19 BPF1IN1
DET
IN2 2
32.768 kHz
0.2V/DIV, 0.2 msec/DIV
20 BPF2OUT
IN1 1
3.1 Vp-p
18 BPF1IN2
17 RECOUT
DET
16 BPF1OUT
BPF
DET
15 BPF2OUT
BPF
DET
14 BPF3OUT
BPF
DET
13 BPF4OUT
BPF2IN1 4
BPF2IN2 5
2.0 Vp-p
BPF3IN1 6
0.4 Vp-p
BPF3IN2 7
16 MHz
0.1V/DIV, 1 msec/DIV
BPF4IN1 8
BPF4IN2 9
1V/DIV, 50 nsec/DIV
GND 10
3 IC101 ra RFAC
3 T301 5
11 VCC
TAPE REC only
– CD Board –
67 Vp-p
0.9 ± 0.4 Vp-p
IC251 BA5947FM-E2
10.5 µsec
0.2V/DIV, 0.5 µsec/DIV
50V/DIV, 10 µsec/DIV
CH4OUTR 15
4 T301 4
12 NC
TAPE REC only
82 Vp-p
CH4OUTF 16
D
CH3OUTF 17
D
CH3OUTR 18
POWVCC 19
10.5 µsec
D
MUTE 20
LEVEL
SHIFT
19k
PIN26
6.5k
D
POW
VCC
(ch3, 4)
10k
POW
VCC
14 CH1OUTF
D
13 CH1OUTR
D
12 CH2OUTF
D
11 CH2OUTR
POW
VCC
(ch1, 2)
Vref
50k 50k
50k 50k
D
POW
VCC
10 POWVCC
9 CNF4
50k 50k
50V/DIV, 10 µsec/DIV
GND 21
8 GND
MUTE
Vref
GND
GND
R
CH3RIN 22
CH3FIN 23
CH4IN 24
CH4CAPA 25
OUTVREF 26
F
HCD-LX10000
48
48
F
R
R
INTER
FACE F
INTER
FACE
F
R
100k
PIN3
10k
50k
7 CH2RIN
6 CH2FIN
5 CH1RIN
INTER
FACE
4 CH1FIN
F
SW
3 SW
2 OPIN+
DPOUT 27
TREVCC 28
F
R
Pre
Vcc
1 OPIN-
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
AD3/PO03
AD2/PO02
AD1/PO01
AD0/PO00
VSS
VDD
CKO/PO13/AD16
VDDX
XO
XI
VSSX
TEST
MIMD
VSSP
VCOI
PO07/AD7 46
AD9 44
Bus
Switch
PO05/AD5 48
VC0
AD10 43
MCU. I/F
round & limit
A1
A3
round & limit
A2
ALU
AY
Audio I/F
Sub code
I/F
DIT
PIO1/SDI3/IO1
PIO0/SDI2/IO0
VSS
CKI/CLOCK/IRQ/FIO
VDD
TXO
SFSY/LRCKIB
SBSY/BCKIB
SDI1/DATA
PIO2/IO2
PIO3/IO3
26
A0
AX
1Mbit
SRAM
PIO4/FI1/BUS0/IO4
27
Y-Bus
X-Bus
C-Pointer
register
PIO5/FI2/BUS1/IO5
28
MAC
MZ
Y-Pointer
register
SRAM I/F
PIO6/FI3/BUS2/IO7
29
MY
register
XO • X1 • X2
Y0 • Y1 • Y2
X-Pointer
register
PO08/AD11 39
CROM
4k word
PO11/BUCK/AD14 36
MX
VDDM 40
CRAM
4k word
PIO7/BUS3/IO7
30
Instruction
Decoder
SRMSTB 41
ERAM
2k word
WE/SDO1
31
Program
Control
YRAM
4k word
PO10/CCE/AD13 37
Address Calc.
2sets
General
In/Output Port
32
PRAM
POM
XRAM
4k word
PO9/AD12 38
SRAM/
DRAM I/F
SDO3/OE 35
CDP Cont
I/F
AD15/CAS/PD12 34
AD4/PO04
HCD-LX10000
– CD Board –
IC301 TC94A34FG-002
25
24
23
22
21
20
19
18
17
CS/RAS/ADO2 33
16 LRCKIA
15 BCKIA
14 SDI0
13 LRCKO
12 BCKO
11 SDO0
10 VSS
9 VDDT
8 MIACK
VDDT 42
7 MICK
6 MIDIO
5 MILP
AD8 45
4 MICS
3 STANBY
PO06/AD6 47
2 RESET
Timing
Generator
1 VDDP
49
HCD-LX10000
7-23. IC Pin Function Descriptions
• IC101 CXD3059AR (RF AMP, DSP, DAC) (CD BOARD)
Pin No.
Pin Name
I/O
1
MIRR
I/O
Not used (Open)
2
DFCT
I/O
Not used (Open)
3
FOK
I/O
Not used (Open)
50
Description
4
VSS
—
Ground
5
LOCK
I/O
Not used (Open)
6
MDP
O
Spindle motor servo control output
Disk innermost detection signal input
7
SSTP
I
8
IOVSS1
—
Ground
9
SFDR
O
Sled drive signal output
10
SRDR
O
Sled drive signal output
11
TFDR
O
Tracking drive signal output
12
TRDR
O
Tracking drive signal output
13
FFDR
O
Focus drive signal output
14
FRDR
O
Focus drive signal output
15
IOVDD1
—
Power supply (+3.3V)
16
AVDD0
—
Power supply (+3.3V)
17
AVSS0
—
Ground
18
NC
—
19
E
I
E signal input
20
F
I
F signal input
Not used (Open)
21
TEI
I
Tracking error signal input
22
TEO
O
Tracking error signal output
23
FEI
I
Focus error signal input
24
FEO
O
Focus error signal output
25
VC
I/O
26
A
I
A signal input
27
B
I
B signal input
28
C
I
C signal input
29
D
I
D signal input
Center voltage output from RF amplifier block
30
NC
—
Not used (Open)
31
AVDD4
—
Power supply (+3.3V)
32
RFDCO
O
RFDC signal output (Not used)
33
PDSENS
I
Reference voltage pin
34
AC_SUM
O
RFAC summing amplifier output
35
EG_IN
I
Equalizer circuit input
36
LD
O
APC LD drive signal output
APC PD signal input
37
PD
I
38
NC
—
39
RFC
I
40
AVSS4
—
Ground
41
RFACO
O
RFAC signal output
RFAC signal input or EFM signal input
Not used (Open)
Equalizer cut-off frequency adjustment pin
42
RFACI
I
43
AVDD3
—
44
BIAS
I
Asymmetry circuit constant current input
45
ASYI
I
Asymmetry comparator voltage input
46
ASYO
O
EFM full-swing output
47
VPCO
O
Not used (Open)
48
VCTL
I
Wide-band EFM PLL VCO2 control voltage input
Power supply (+3.3V)
HCD-LX10000
Pin No.
Pin Name
I/O
Description
49
AVSS3
—
50
CLTV
I
Multiplier VCO1 control voltage input
51
FILO
O
Master PLL (slave = digital PLL) filter output
Ground
52
FILI
I
Master PLL filter input
53
PCO
O
Master PLL charge pump output
54
AVDD5
—
Power supply (+3.3V)
55
DDVROUT
O
DC/DC converter output (+2.5V)
56
DDVRSEN
I
DC/DC converter output voltage monitor input
57
AVSS5
—
58
DDCR
I
59
NC
—
60
BCKI
I
D/A interface bit clock input
61
PCMDI
I
D/A interface serial data input
62
LRCKl
I
D/A interface LR clock input
63
LRCK
O
D/A interface LR clock output f = Fs
64
VSS
—
Ground
65
PCMD
O
D/A interface serial data output
Ground
DC/DC converter reset input
Not used (Open)
66
BCK
O
D/A interface bit clock output
67
VDD
—
Power supply (+2.5V)
68
EMPH
O
High when the playback disc has emphasis, low it has not
69
EMPHI
I
70
IOVDD2
—
High when de-emphasis is ON, low when input OFF
71
DOUT
O
Digital Out output
72
TEST
I
Test pin (Connected ground)
Test pin (Connected ground)
Power supply (+3.3V)
73
TEST1
I
74
IOVSS2
—
Ground
75
NC
—
Not used (Open)
76
XVSS
—
Ground
77
XTAO
O
Crystal oscillation circuit output
78
XTAI
I
79
XVDD
—
Power supply (+2.5V)
Crystal oscillation circuit input
80
AVDD1
—
Power supply (+3.3V)
81
AOUT1
O
L-ch analog output
82
VREFL
O
L-ch reference voltage
83
AVSS1
—
Ground
84
AVSS2
—
Ground
85
VREFR
O
R-ch reference voltage
86
AOUT2
O
R-ch analog output
87
AVDD2
—
Power supply (+3.3V)
88
NC
—
Not used (Open)
89
IOVDD0
—
Power supply (+3.3V)
90
RMUT
O
Not used (Open)
91
LMUT
O
Not used (Open)
92
NC
—
93
XTSL
I
94
IOVSS0
—
95
XTACN
I
Oscillation circuit control (H:Self-oscillation, L:oscillation stop)
96
SQSO
O
Not used (Open)
97
SQCK
I
SQSO readout clock input (Connected to +VDD(+3.3v))
98
SBSO
O
Not used (Open)
Not used (Open)
Crystal selection input (Pull down)
Ground
51
HCD-LX10000
Pin No.
Pin Name
I/O
99
EXCK
I
Not used (Open)
100
XRST
I
System reset input from M30622MEP
101
SYSM
I
Mute input (Connected to ground)
102
DATA
I
Serial data input from M30622MEP
103
VSS
—
104
XLAT
I
Latch input from M30622MEP
105
CLOCK
I
Serial data transfer clock input from M30622MEP
106
VDD
—
Power supply (+2.5V)
107
SENS
O
SENS output to M30622MEP
108
SCLK
I
109
ATSK
I/O
110
WFCK
O
Not used (Open)
111
XUGF
O
Not used (Open)
112
XPCK
O
Not used (Open)
113
GFS
O
Not used (Open)
114
C2PO
O
Not used (Open)
115
SCOR
O
High output when the sub code sync, S0 or S1, is detected
116
VDD
—
Power supply (+2.5V)
52
Description
ground
SENS serial data readout clock input (Connected to +VDD(+3.3v))
Not used (Open)
117
C4M
O
Not used (Open)
118
WDCK
O
Not used (Open)
119
COUT
I/O
Not used (Open)
120
NC
—
Not used (Open)
HCD-LX10000
• IC401 M30622MEP-A77FPU0 SYSTEM CONTROL (MAIN BOARD)
Pin No.
Pin Name
I/O
Description
1
XRST
O
Reset signal output to CXD3053AR
2
CD-DATA
O
Serial data output to CXD3053AR
3
XLAT
O
Serial data latch signal output to CXD3053AR
4
SIRCS
I
Remote control signal input
5
MP3 DATA OUT
O
Serial data output to TC94A34FG
6
MP3 DATA IN
I
Serial data input from TC94A34FG
7
MP3 CLK
O
Serial data transfer clock output to TC94A34FG
Not used (Connected to ground)
8
BYTE
I
9
CNVSS
—
10
XC-IN
I
Sub system clock input (32.768KHz)
Ground at test (Pull down)
11
XC-OUT
O
Sub system clock output (32.768KHz)
12
RESET
I
System reset input
13
X-OUT
O
Main system clock output (16MHz)
14
VSS
—
Ground
15
X-IN
I
16
VCC
—
17
NMI
I
Not used (Pull up with resistor)
18
CD-CLK
O
CD data clock output
19
SCOR
I
Sub code sync (S0+S1) detection signal input
20
AC-CUT
I
AC off detection signal input
21
SENS
I
Internal status detection monitor input from CXD3059AR
22
MP3 RST
O
Reset signal output to TC94A34FG
23
MP3 CS
O
Chip select signal output to TC94A34FG
24
MP3 LP
O
Latch pulse output to TC94A34FG
25
MP3 ACK
I
Acknowledge signal input from TC94A34FG
26
MP3 REQ
I
Request signal input to TC94A34FG
27
MP3 STB
O
Standby mode signal output to TC94A34FG
28
XTCN
O
Oscillation on/off control signal output to CXD3053AR
29
IIC-CLK
I/O
IIC bus serial clock input/output
30
IIC-DATA
I/O
IIC bus serial data input/output
31
VMUTE
O
32
CD POWER
O
Not used (Open)
33
CDG DET
I
Not used (Open)
34
CDG/BGC
O
Not used (Open)
35
CDG RST
O
Not used (Open)
36
FAN KICK-OFF
O
Fan kick off pulse to start up fan rotation signal output
37
CD MUTE
O
CD muting on/off control signal output
38
OPEN SW
I
Eject detection signal input
39
TBL-SENS
I
Disc tray position detection signal input
40
E-3
I
Disc tray status detection signal input
41
E-2
I
Disc tray status detection signal input
42
E-1
I
Disc tray status detection signal input
Main system clock input (16MHz)
Power supply (+5V)
CDG video signal muting on/off control signal output
43
TM-F
O
Table motor control signal output
44
TM-R
O
Table motor control signal output
45
LMF
O
Table loading motor control signal output
46
LMR
O
Table loading motor control signal output
47
A-PLAY
I
Deck A playback detection signal input
48
A-HALF
I
Deck A cassette detection signal input
49
SW LED1
O
Not used (Open)
53
HCD-LX10000
Pin No.
Pin Name
I/O
50
SW LED2
O
Not used (Open)
51
B-PLAY
I
Deck B playback detection signal input
52
THERMAL VACS
I
Thermal VACS detection input
53
A-TRIG
O
Deck A side trigger plunger drive signal output
54
CAPM-CONT
O
Capstan motor drive signal output
55
B-TRIG
O
Deck B side trigger plunger drive signal output
56
REC BIAS
O
Recording bias on/off control signal output
57
TC-RELAY
O
Recording/playback selection signal output
58
ALC
O
Automatic limiter control signal output
59
PB-AB
O
Deck A/B playback selection signal output
60
AMS-IN
I
Not used.
61
UNDER VOLTAGE DET
I
62
VCC
—
63
OVER VOLTAGE
I
64
VSS
—
Ground
65
TC MUTE
O
Tape playback muting on/off signal output
66
LINE MUTE
O
Line muting on/off signal output
67
REC MUTE
O
Recording muting on/off signal output
68
SW RY
O
Not used (Open)
69
STBY-RLY
O
Main power on/off signal output
54
Description
Under-voltage protection detection input (Connected to ground)
Power supply(+3.3V)
Over-voltage protection detection input (Not used)
70
PROT
I
Speaker protect detection signal input
71
GC-RESET
O
GC reset signal output
72
STBY-LED/FAN CTRL
O
POWER indicator LED drive signal output
73
DISPLAY-KEY
I
DISPLAY key press detection Interrupt signal input
74
POWER-KEY
I
POWER key press detection Interrupt signal input
75
HP-MUTE
O
Headphone muting on/off signal output
76
FR RELAY
O
front speakers relay drive signal output
77
LINK/SURR-RLY
O
Surround speaker mode control signal output
78
STK-MUTE
O
Power amplifier and sub woofer amplifier on/off control signal output
79
M61530-DATA
O
Not used (Open)
80
M61530-CLK
O
Not used (Open)
81
M61529-DATA
O
Serial data output to M61529FP
82
M61529-CLK
O
Serial transfer clock signal output to M61529FP
83
SW ON LED
O
Not used (Open)
84
ST-CE
O
PLL chip enable signal output to the tuner unit
85
MC DIN (ST)
O
PLL serial data output to the tuner unit
86
ST-CLK
I
PLL serial transfer clock signal output to the tuner unit
87
MC DOUT (ST)
I
PLL serial data input from the tuner unit
88
TUNED
I
Tuning detection signal input from the tuner unit
89
A SHUT
I
Shut off detection signal input from deck A side reel pulse detector
90
B SHUT
I
Shut off detection signal input from deck A side reel pulse detector
91
SW AD KEY
I
Not used (pull up)
92
MODEL-IN
I
Model setting input
93
DEST-IN
I
Destination input
94
B-HALF
I
Deck B cassette , forward side recording tab and reverse side recording tab detection signal input
95
SW VOL IN
I
Subwoofer on/off signal input
96
AVSS
—
97
BPF DET
I
Low frequency signal input from NJM2760 for RANDOM mode
98
VREF
I
A/D reference voltage input
99
AVCC
—
100
HP DET
I
Ground
Power supply (+3.3V)
Headphone connection detection signal input
HCD-LX10000
• IC902 MB90M407PF-G-144E1 DISPLAY CONTROL (PANEL Board)
Pin No.
Pin Name
I/O
Description
1 to 8
G8 to G1
O
FLD grid signal output
9, 10
P1,P2
O
FLD segment signal output
11
VSS-IO
—
Ground
12 to 22
P3 to P13
O
FLD segment signal output
23
VDD-FIP
—
Power supply (+3.3V)
24 to 41
P14 to P31
O
FLD segment signal output
42
VSS-IO
—
Ground
43 to 47
P32 to P36
O
FLD segment signal output
48
VKK
—
Power supply (-35V)
49
MD0
I
50
MD1/VDD-VFT
I
Not used (pull up)
51
MD2
I
Not used (pull down)
52
LED CD/DVD
O
LED drive signal output
53
LED TUNER
O
LED drive signal output
54
LED TAPE
O
LED drive signal output
55
LED VIDEO
O
LED drive signal output
56
LED STOP,PAUSE
O
LED drive signal output
57
LED VOLUME 2,3
O
LED drive signal output
58
LED VOLUME 4,5
O
LED drive signal output
59
LED VOLUME 6,1
O
60
IIC DATA
I/O
IIC bus serial data input/output
61
IIC CLK
I/O
IIC bus serial clock input/output
62
AVCC
—
Power supply (+3.3V)
63
AVSS
—
Ground
64 to 66
KEY0 to KEY2
I
Key input (A/D)
67
ALL BAND
I
Audio L+R signal input
MD0 signal at test
LED drive signal output
68 to 71
BPF4 to BPF1
I
Spectrum analyzer signal input
72
LED VIDEO/MD
O
LED drive signal output
73
X-ROUND JOG
O
X-ROUND JOG encoder signal input
74
VOLUME
I
Volume encoder signal input
75
OPERATION DIAL
I
JOG dial encoder signal input
76
AMS
I
AMS dial signal input
77
RESET
I
Reset input
78
LED AMS+/-,FF/FW
O
LED drive signal output
79
LED PLAY
O
LED drive signal output
80
SELECTOR
O
LED group select signal output
81
VSS-CPU
—
Ground
82
XOUT
O
Crystal oscillator output (4MHz)
Crystal oscillator input (4MHz)
83
XIN
I
84
VCC-CPU
—
Power supply (+3.3V)
85 to 100
G24 to G9
O
FLD grid signal output
55
HCD-LX10000
SECTION 8
EXPLODED VIEWS
NOTE:
• -XX, -X mean standardized parts, so they may
have some differences from the original one.
• Items marked “*” are not stocked since they
are seldom required for routine service. Some
delay should be anticipated when ordering these
items.
• The mechanical parts with no reference number
in the exploded views are not supplied.
•
Hardware (# mark) list and accessories are
given in the last of this parts list.
The components identified by mark 0 or
dotted line with mark 0 are critical for
safety.
Replace only with part number specified.
#1
8-1.
CASE (TOP), BACK PANEL SECTION
3
#1
2
not supplied
not supplied
#1
#1
#1
#1
4
CD mechanism
deck section
1
#1
M891
#1
#1
#1
10
6
#2
#1
9
5
not supplied
#1
#1
not
supplied
not supplied
#2
8
#2
7
#1
not supplied
9
#1
3
#1
not supplied
#1
not supplied
4
Ref. No.
1
2
3
4
5
Part No.
X-2109-678-1
2-342-117-21
3-363-099-32
3-363-099-02
1-693-672-11
6
07
A-1089-525-A PRIMARY BOARD, COMPLETE
1-468-737-61 POWER SWITCHING
56
Description
LOADING PANEL ASSY
CASE (TOP)
SCREW (CASE 3 TP2)
SCREW (CASE 3 TP2)
TUNER (FM/AM) (TM-10U)
Remarks
Ref. No.
8
9
10
M891
#1
#2
Part No.
1-824-048-12
3-077-331-21
3-378-109-12
1-763-372-11
7-685-647-79
Description
WIRE (FLAT TYPE) (27 CORE)
+BV3 (3-CR)
CUSHION, SARANET
FAN, DC
SCREW +BVTP 3X10 TYPE2 IT-3
7-685-646-79 SCREW +BVTP 3X8 TYPE2 IT-3
Remarks
HCD-LX10000
8-2.
FRONT PANEL SECTION
58
58
58
64
not supplied
58
FL901
68
65
66
58
69
58
67
not supplied
58
69
not supplied
not supplied
58
70
58
60
62
59
61
not supplied
58
56
57
58
56
58
58
not supplied
55
54
71
52 53
51
Ref. No.
Part No.
Description
51
52
53
54
55
X-2025-429-1
2-342-128-01
2-342-108-01
2-342-134-01
2-342-111-01
FRONT PANEL ASSY
ESCUTHEON (LID)
LID (TC)
SPRING (LID)
HOLDER (TC-R)
56
57
58
59
60
4-959-229-11
2-342-110-01
3-087-053-01
4-224-578-21
2-342-104-01
DETENT, CASSETTE
HOLDER (TC-L)
+BVTP2.6 (3CR)
KNOB (MIC)
KNOB (AMS)
61
4-252-575-01 KNOB VOL
Remarks
Ref. No.
Part No.
Description
62
64
65
66
X-2025-430-1
3-077-331-21
1-828-992-11
A-1089-463-A
KNOB JOG ASSY
+BV3 (3-CR)
WIRE (FLAT TYPE) (17 CORE)
PANEL BOARD, COMPLETE
67
68
69
70
71
2-342-136-01
2-342-135-01
4-224-104-11
A-1089-466-A
1-797-165-11
SPRING (R)
SPRING (L)
DAMPER
MIC BOARD, COMPLETE
DECK, MECHANICAL (CMAT5Z2)
FL901
1-519-794-21 VACUUM FLUORESCENT DISPLAYS
Remarks
57
HCD-LX10000
8-3.
CHASSIS SECTION
104
#1
not supplied
111
103
not supplied
#1
107
108
#1
111
111
not supplied
F1281
111
F1271
F1261
F1251
105
106
F1241
101
102
#1
#1
101
T1200
#1
#1
109
#1
110
not supplied
Ref. No.
101
102
103
104
105
Part No.
4-900-386-01
A-1089-586-A
A-1089-588-A
A-1089-321-A
3-905-609-31
Description
SCREW
PA BOARD, COMPLETE
TRANS BOARD, COMPLETE
SURROUND BOARD, COMPLETE
SCREW (TRANSISTOR)
106
0 107
* 108
109
1-828-956-11
1-783-820-11
3-703-244-00
1-828-972-11
WIRE (FLAT TYPE) (9 CORE)
CORD, POWER
BUSHING (2104), CORD
WIRE (FLAT TYPE) (13 CORE)
58
Remarks
Ref. No.
110
Part No.
Description
A-1189-960-A MAIN BOARD, COMPLETE
Remarks
111
0 F1241
0 F1251
0 F1261
0 F1271
3-077-331-21
1-576-537-12
1-576-537-12
1-576-537-12
1-576-537-12
0 F1281
0 T1200
#1
1-533-451-12 FUSE, GLASS TUBE (DIA.5) (T3.15AL/125V)
1-443-544-11 POWER TRANSFORMER
7-685-647-79 SCREW +BVTP 3X10 TYPE2 IT-3
+BV3 (3-CR)
FUSE, GLASS TUBE (DIA.5) (T8AL/125V)
FUSE, GLASS TUBE (DIA.5) (T8AL/125V)
FUSE, GLASS TUBE (DIA.5) (T8AL/125V)
FUSE, GLASS TUBE (DIA.5) (T8AL/125V)
HCD-LX10000
8-4. CD MECHANISM DECK SECTION-1
(CDM74-F1BD81)
156
162
158
151
156
157
158
156
157
163
159
161
164
164
165
160
155
155
M741
152
154
153
166
CD mechanism deck section-2
151
Ref. No.
Part No.
Description
151
152
153
154
155
4-218-253-32
1-776-182-11
1-687-134-12
4-243-815-01
4-245-571-02
SCREW (M2.6), +BTTP
WIRE (FLAT TYPE) (5 CORE)
MOTOR (TB) BOARD
TABLE (LOADING)
GEAR (STOPPER)
156
157
158
159
4-218-252-61
4-245-570-01
4-245-572-01
1-687-132-12
SCREW (+PTPWH M2.6), FLOATING
GEAR (JOINT)
BUSHING (GEAR)
SENSOR BOARD
Remarks
Ref. No.
160
Part No.
Description
4-243-820-01 GEAR (TABLE)
161
162
163
164
165
4-243-819-01
4-243-816-01
4-243-823-01
4-985-672-01
4-243-821-01
166
M741
3-231-598-01 SHEET (BA)
A-4723-963-A MOTOR ASSY, TABLE
Remarks
GEAR (GENEVA)
TRAY
BELT (TABLE)
SCREW (+PTPWH M2.6), FLOATING
PULLY (TABLE)
59
HCD-LX10000
8-5.
CD MECHANISM DECK SECTION-2
(CDM74-F1BD81)
212
205
213
205
216
214
211
217
205
215
210
219
231
220
RE701
202
205
208
222
229
205
223
222
222
M751
230
223
224
223
222
223 225 233
225
224
207
203
206
218
202
201
205
226
228
202
204
not supplied
232
Ref. No.
201
202
203
204
205
Part No.
1-687-135-12
4-218-253-52
1-687-669-12
4-244-034-01
4-218-252-52
Description
DRIVER BOARD
SCREW (M2.6), +BTTP
SW BOARD
BELT (LOADING)
SCREW (+PTPWH M2.6), FLOATING
206
207
208
210
211
4-225-844-01
4-224-613-01
1-687-133-12
4-244-108-01
4-224-609-01
GEAR (LOADING A)
GEAR (SHAFT)
MOTOR (LD) BOARD
GEAR, SWING
GEAR (LOADING C)
212
213
214
215
216
4-224-608-01
3-016-533-11
4-224-611-01
4-224-606-01
4-243-818-01
COLLAR, SWING
WASHER (FR), STOPPER
GEAR (LOADING B)
GEAR (RV)
GEAR (U/D)
217
4-243-822-02 LEVER (LIFTER)
60
Remarks
Ref. No.
Part No.
Description
218
219
220
222
X-4955-774-2
4-221-688-01
X-2055-190-1
4-227-549-11
PULLEY (SM) ASSY, CHUCKING
PULLEY (B), CHUCKING
HOLDER (213) ASSY
INSULATOR
223
224
225
226
228
4-227-045-11
4-231-151-01
4-218-253-42
1-832-404-21
A-4751-045-A
SPRING (INSULATOR), COIL
STOPPER (BU)
SCREW (M2.6), +BTTP
CABLE, FLEXIBLE FLAT (16 CORE)
CD BOARD, COMPLETE
0 229
230
231
232
233
8-820-244-01
1-471-035-11
4-243-817-22
3-087-053-01
4-985-672-01
OPTICAL PICK-UP KSM-215DCP/C2NP
MAGNET ASSY
CHASSIS
+BVTP2.6 (3CR)
SCREW (+PTPWH M2.6), FLOATING
M751
RE701
A-4737-553-A MOTOR ASSY, LOADING
1-477-680-12 ENCODER, ROTARY
Remarks
HCD-LX10000
SECTION 9
CD
ELECTRICAL PARTS LIST
NOTE:
• Due to standardization, replacements in the
parts list may be different from the parts
specified in the diagrams or the components
used on the set.
• -XX, -X mean standardized parts, so they
may have some difference from the original
one.
• Items marked “*” are not stocked since they
are seldom required for routine service.
Some delay should be anticipated when
ordering these items.
• CAPACITORS:
uF: µF
• RESISTORS
All resistors are in ohms.
METAL: metal-film resistor
METAL OXIDE: Metal Oxide-film resistor
F: nonflammable
Ref. No.
Part No.
Description
•
•
COILS
uH: µH
SEMICONDUCTORS
In each case, u: µ, for example:
uA...: µA... , uPA... , µPA... ,
uPB... , µPB... , uPC... , µPC... ,
uPD..., µPD...
Remarks
A-4751-045-A CD BOARD, COMPLETE
*******************
< CAPACITOR >
C10
C11
C14
C15
C16
1-165-989-11
1-165-989-11
1-164-360-11
1-164-360-11
1-115-156-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
10uF
10uF
0.1uF
0.1uF
1uF
10%
10%
C17
C18
C111
C112
C113
1-126-246-11
1-162-964-11
1-162-967-11
1-164-315-11
1-162-967-11
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
220uF
0.001uF
0.0033uF
470PF
0.0033uF
20%
10%
10%
5%
10%
4V
50V
50V
50V
50V
C114
C115
C116
C122
C123
1-164-315-11
1-164-360-11
1-128-995-21
1-107-826-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
470PF
0.1uF
100uF
0.1uF
0.1uF
5%
50V
16V
10V
16V
16V
20%
10%
10%
5%
6.3V
6.3V
16V
16V
10V
C124
C125
C131
C132
C133
1-162-959-11
1-164-360-11
1-162-927-11
1-117-863-11
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
330PF
0.1uF
100PF
0.47uF
0.01uF
5%
10%
10%
50V
16V
50V
6.3V
25V
C134
C141
C142
C143
C151
1-164-360-11
1-107-826-11
1-162-965-11
1-164-360-11
1-128-995-21
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
0.1uF
0.1uF
10%
0.0015uF 10%
0.1uF
100uF
20%
16V
16V
50V
16V
10V
C161
C162
C163
C171
C172
1-164-360-11
1-164-360-11
1-164-360-11
1-162-919-11
1-162-920-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
22PF
27PF
5%
5%
16V
16V
16V
50V
50V
C174
C181
C182
C183
C184
1-164-360-11
1-164-360-11
1-164-360-11
1-124-778-00
1-124-778-00
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
ELECT CHIP
0.1uF
0.1uF
0.1uF
22uF
22uF
20%
20%
16V
16V
16V
6.3V
6.3V
C185
C186
1-164-315-11 CERAMIC CHIP
1-164-315-11 CERAMIC CHIP
470PF
470PF
5%
5%
50V
50V
The components identified by mark 0
or dotted line with mark 0 are critical
for safety.
Replace only with part number specified.
When indicating parts by reference
number, please include the board.
Ref. No.
C194
C195
C196
Part No.
1-164-360-11
1-164-360-11
1-164-360-11
Description
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
Remarks
16V
16V
16V
C201
C203
C209
C210
C211
1-128-995-21
1-128-995-21
1-162-970-11
1-107-826-11
1-164-230-11
ELECT CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100uF
100uF
0.01uF
0.1uF
220PF
20%
20%
10%
10%
5%
10V
10V
25V
16V
50V
C212
C213
C251
C252
C255
1-162-919-11
1-162-919-11
1-162-969-11
1-164-360-11
1-164-360-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
22PF
5%
22PF
5%
0.0068uF 10%
0.1uF
0.1uF
50V
50V
25V
16V
16V
C257
C258
C259
C260
C302
1-164-360-11
1-164-360-11
1-164-360-11
1-128-394-11
1-164-360-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
220uF
0.1uF
16V
16V
16V
10V
16V
C303
C305
C306
C307
C308
1-164-360-11
1-126-246-11
1-164-360-11
1-164-360-11
1-126-208-21
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
0.1uF
220uF
0.1uF
0.1uF
47uF
C309
C310
C311
C312
C313
1-164-360-11
1-164-360-11
1-164-360-11
1-164-360-11
1-164-360-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
C314
C315
C316
C317
C318
1-126-208-21
1-107-826-11
1-162-966-11
1-162-970-11
1-162-970-11
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
47uF
0.1uF
0.0022uF
0.01uF
0.01uF
C320
1-216-864-11 SHORT CHIP
20%
20%
20%
16V
4V
16V
16V
4V
16V
16V
16V
16V
16V
20%
10%
10%
10%
10%
4V
16V
50V
25V
25V
0
< CONNECTOR >
CN101
CN201
1-770-425-51 CONNECTOR, FFC/FPC 16P
1-818-350-51 CONNECTOR, FFC (LIF (NON-ZIF)) 27P
< FERRITE BEAD >
FB301
1-500-445-21 FERRITE, EMI (SMD) (2012)
61
HCD-LX10000
CD
Ref. No.
CD-SW
DRIVER
Part No.
Description
Remarks
< IC >
IC101
IC251
IC301
IC303
8-752-425-12
6-705-808-01
6-705-365-01
6-705-807-01
IC
IC
IC
IC
CXD3059AR
BA5947FM-E2
TC94A34FG-002
BH15FB1WG
< TRANSISTOR >
Q10
Ref. No.
Part No.
Description
Remarks
R404
R405
R406
1-216-809-11 METAL CHIP
1-216-809-11 METAL CHIP
1-216-809-11 METAL CHIP
100
100
100
5%
5%
5%
1/10W
1/10W
1/10W
R407
R408
R409
R410
R411
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R412
R419
R502
1-216-809-11 METAL CHIP
1-216-809-11 METAL CHIP
1-216-864-11 SHORT CHIP
100
100
0
5%
5%
1/10W
1/10W
6-551-120-01 TRANSISTOR 2SA2119K
< RESISTOR >
R10
R11
R12
R13
R111
1-216-791-11
1-216-864-11
1-216-845-11
1-218-446-11
1-216-821-11
METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
3.3
0
100K
1
1K
5%
1/10W
5%
5%
5%
1/10W
1/10W
1/10W
R112
R113
R114
R121
R131
1-216-835-11
1-216-821-11
1-216-835-11
1-216-835-11
1-216-857-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
15K
1K
15K
15K
1M
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R132
R133
R141
R142
R143
1-216-833-11
1-216-848-11
1-216-829-11
1-216-821-11
1-216-827-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
180K
4.7K
1K
3.3K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R151
R161
R162
R163
R165
1-216-864-11
1-216-809-11
1-216-841-11
1-216-809-11
1-216-864-11
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
0
100
47K
100
0
5%
5%
5%
1/10W
1/10W
1/10W
R171
R172
R173
R181
R182
1-216-817-11
1-216-857-11
1-216-295-91
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
470
1M
0
100
100
5%
5%
1/10W
1/10W
5%
5%
1/10W
1/10W
R191
R201
R203
R204
R205
1-216-864-11
1-500-445-21
1-216-864-11
1-500-445-21
1-216-864-11
SHORT CHIP
0
FERRITE, EMI (SMD) (2012)
SHORT CHIP
0
FERRITE, EMI (SMD) (2012)
SHORT CHIP
0
R251
R252
R253
R301
R302
1-216-833-11
1-216-837-11
1-216-833-11
1-216-845-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
22K
10K
100K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R303
R305
R306
R307
R313
1-216-845-11
1-216-845-11
1-216-864-11
1-216-833-11
1-216-813-11
METAL CHIP
METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
100K
100K
0
10K
220
5%
5%
1/10W
1/10W
5%
5%
1/10W
1/10W
R351
R352
R353
R354
R401
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R402
R403
1-216-809-11 METAL CHIP
1-216-809-11 METAL CHIP
100
100
5%
5%
1/10W
1/10W
< SWITCH >
S101
1-771-853-11 SWITCH DETECTION (LIMIT)
< VIBRATOR >
62
X171
1-767-408-21 VIBRATOR, CRYSTAL (16.9MHz)
*************************************************************
CD-SW BOARD
************
< RESISTOR >
R1169
R1171
R1172
R1173
R1174
1-216-817-11
1-216-823-11
1-216-823-11
1-216-821-11
1-216-819-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
470
1.5K
1.5K
1K
680
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
< SWITCH >
S1156 1-762-875-21 SWITCH, KEYBOARD (DISC 1)
S1157 1-762-875-21 SWITCH, KEYBOARD (DISC 2)
S1158 1-762-875-21 SWITCH, KEYBOARD (DISC 3)
S1159 1-762-875-21 SWITCH, KEYBOARD (EX-CHANGE/DISC SKIP)
S1160 1-762-875-21 SWITCH, KEYBOARD (Z OPEN/CLOSE)
*************************************************************
1-687-135-12 DRIVER BOARD
*************
< CAPACITOR >
C715
C731
C735
C736
C737
1-126-933-11
1-126-964-11
1-164-159-11
1-164-159-11
1-164-159-11
ELECT
ELECT
CERAMIC
CERAMIC
CERAMIC
100uF
10uF
0.1uF
0.1uF
0.1uF
20%
20%
16V
50V
50V
50V
50V
C741
C751
C752
1-162-306-11 CERAMIC
1-162-306-11 CERAMIC
1-164-159-11 CERAMIC
0.01uF
0.01uF
0.1uF
20%
20%
16V
16V
50V
< CONNECTOR >
CN701
CN702
* CN703
CN704
1-785-338-11
1-784-766-11
1-564-720-11
1-785-328-11
PIN, CONNECTOR (LIGHT ANGLE) 12P
CONNECTOR, FFC 5P
PIN, CONNECTOR (SMALL TYPE) 4P
PIN, CONNECTOR (LIGHT ANGLE) 2P
< DIODE >
D701
D711
8-719-947-16 DIODE MTZJ-T-72-5.1A
8-719-983-66 DIODE MTZJ-T-72-3.6B
HCD-LX10000
DRIVER
Ref. No.
Part No.
Description
Remarks
Ref. No.
JOG
LIGHTING
MAIN
Part No.
Description
Remarks
R1146
R1156
R1157
R1158
R1159
1-216-820-11
1-216-821-11
1-216-820-11
1-216-820-11
1-216-820-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
820
1K
820
820
820
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R1190
R1191
R1192
1-216-809-11 METAL CHIP
1-216-809-11 METAL CHIP
1-216-809-11 METAL CHIP
100
100
100
5%
5%
5%
1/10W
1/10W
1/10W
< IC >
IC701
IC712
8-759-598-69 IC BA6956AN
8-759-598-69 IC BA6956AN
< TRANSISTOR >
Q731
8-729-029-66 TRANSISTOR DTC114ESA
< RESISTOR >
R701
R702
R711
R712
R713
1-249-413-11
1-247-807-31
1-247-831-91
1-247-847-91
1-247-863-91
CARBON
CARBON
CARBON
CARBON
CARBON
470
100
1K
4.7K
22K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R721
R722
R723
R731
R732
1-247-847-91
1-247-847-91
1-247-847-91
1-247-807-31
1-249-429-11
CARBON
CARBON
CARBON
CARBON
CARBON
4.7K
4.7K
4.7K
100
10K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R733
1-247-831-91 CARBON
1K
5%
1/4W
R734
1-249-430-11 CARBON
12K
5%
1/4W
R735
1-247-807-31 CARBON
100
5%
1/4W
R751
1-247-847-91 CARBON
4.7K
5%
1/4W
*************************************************************
< SWITCH >
S1161 1-479-203-11 ENCODER (ROTARY) (OPERATION DIAL)
************************************************************
A-1172-532-A LIGHTING BOARD
**************
< CAPACITOR >
C06
C07
1-162-970-11 CERAMIC CHIP
1-164-156-11 CERAMIC CHIP
0.01uF
0.1uF
10%
25V
25V
< CONNECTOR >
CN01
1-564-705-11 PIN, CONNECTOR (SMALL TYPE) 3P
< DIODE >
JOG BOARD
**********
D01
D02
D03
< CAPACITOR >
C1150
1-162-964-11 CERAMIC CHIP
0.001uF
10%
6-501-193-01 DIODE 1SS355WTE-17
6-501-193-01 DIODE 1SS355WTE-17
8-719-083-60 DIODE UDZSTE-174.7B
< JACK >
50V
J01
< CONNECTOR >
1-820-048-11 CONNECTOR (LIGHTING) (D-LIGHT SYNC OUT)
< TRANSISTOR >
* CNS903 1-562-573-11 SOCKET, CONNECTOR 8P
Q01
< DIODE >
D919
D920
D921
D922
D923
6-500-809-01
6-500-809-01
6-500-809-01
6-500-809-01
6-500-809-01
DIODE
DIODE
DIODE
DIODE
DIODE
D924
6-500-809-01 DIODE SELU5223C-STP15 (VOL 1)
< RESISTOR >
SELU5223C-STP15 (VOL 2)
SELU5223C-STP15 (VOL 3)
SELU5223C-STP15 (VOL 4)
SELU5223C-STP15 (VOL 5)
SELU5223C-STP15 (VOL 6)
R01
1-216-809-11 METAL CHIP
100
5%
1/10W
R03
1-216-819-11 METAL CHIP
680
5%
1/10W
R05
1-216-864-11 SHORT CHIP
0
************************************************************
A-1189-961-A MAIN BOARD, COMPLETE
*******************
< JUMPER RESISTOR >
JR904
JR905
1-216-296-11 SHORT CHIP
1-216-864-11 SHORT CHIP
8-729-056-46 TRANSISTOR 2SC5053T100Q
7-685-646-79 SCREW +BVTP 3X8 TYPE2 IT-3
0
0
< CAPACITOR >
< TRANSISTOR >
Q911
Q912
Q913
8-729-027-43 TRANSISTOR DTC114EKA-T146
8-729-027-43 TRANSISTOR DTC114EKA-T146
8-729-027-43 TRANSISTOR DTC114EKA-T146
C100
C102
C103
C104
C105
1-104-658-91
1-126-964-11
1-126-964-11
1-126-964-11
1-126-964-11
ELECT
ELECT
ELECT
ELECT
ELECT
100uF
10uF
10uF
10uF
10uF
20%
20%
20%
20%
20%
10V
50V
50V
50V
50V
C106
C107
C108
C109
C110
1-164-227-11
1-164-227-11
1-164-677-11
1-126-960-11
1-162-974-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
0.022uF
0.022uF
0.033uF
1uF
0.01uF
10%
10%
10%
20%
25V
25V
16V
50V
50V
< RESISTOR >
R1138
R1139
R1140
R1144
R1145
1-216-820-11
1-216-820-11
1-216-820-11
1-216-820-11
1-216-820-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
820
820
820
820
820
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
63
HCD-LX10000
MAIN
Ref. No.
Part No.
Description
C111
C112
C113
C114
C115
1-126-964-11
1-136-170-00
1-136-170-00
1-126-964-11
1-164-156-11
ELECT
FILM
FILM
ELECT
CERAMIC CHIP
10uF
0.27uF
0.27uF
10uF
0.1uF
20%
5%
5%
20%
50V
50V
50V
50V
25V
C116
C121
C122
C130
C131
1-126-923-91
1-162-957-11
1-162-957-11
1-126-964-11
1-126-959-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
220uF
220PF
220PF
10uF
0.47uF
20%
5%
5%
20%
20%
10V
50V
50V
50V
50V
C140
C149
C150
C152
C153
1-136-495-11
1-164-156-11
1-126-964-11
1-126-964-11
1-126-964-11
FILM
CERAMIC CHIP
ELECT
ELECT
ELECT
0.068uF
0.1uF
10uF
10uF
10uF
5%
20%
20%
20%
50V
25V
50V
50V
50V
C154
C155
C156
C157
C158
1-126-964-11
1-126-964-11
1-164-227-11
1-164-227-11
1-164-677-11
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
10uF
10uF
0.022uF
0.022uF
0.033uF
20%
20%
10%
10%
10%
50V
50V
25V
25V
16V
C159
C160
C161
C162
C163
1-126-960-11
1-162-974-11
1-126-964-11
1-136-170-00
1-136-170-00
ELECT
CERAMIC CHIP
ELECT
FILM
FILM
1uF
0.01uF
10uF
0.27uF
0.27uF
20%
20%
5%
5%
50V
50V
50V
50V
50V
C180
C181
C250
C251
C260
1-126-963-11
1-126-963-11
1-126-964-11
1-126-964-11
1-162-957-11
ELECT
ELECT
ELECT
ELECT
CERAMIC CHIP
4.7uF
4.7uF
10uF
10uF
220PF
20%
20%
20%
20%
5%
50V
50V
50V
50V
50V
C261
C262
C263
C264
C280
1-162-957-11
1-162-957-11
1-162-957-11
1-117-863-11
1-126-964-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
220PF
220PF
220PF
0.47uF
10uF
5%
5%
5%
10%
20%
50V
50V
50V
6.3V
50V
C281
C301
C303
C304
C305
1-126-964-11
1-136-967-11
1-136-497-81
1-126-964-11
1-126-960-11
ELECT
FILM
FILM
ELECT
ELECT
10uF
0.012uF
0.1uF
10uF
1uF
20%
5%
5%
20%
20%
50V
100V
50V
50V
50V
C306
C307
C308
C309
C310
1-126-961-11
1-126-964-11
1-126-925-91
1-126-947-11
1-126-964-11
ELECT
ELECT
ELECT
ELECT
ELECT
2.2uF
10uF
470uF
47uF
10uF
20%
20%
20%
20%
20%
50V
50V
10V
35V
50V
C311
C312
C314
C340
C341
1-126-964-11
1-126-964-11
1-162-966-11
1-162-968-11
1-162-968-11
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
10uF
10uF
0.0022uF
0.0047uF
0.0047uF
20%
20%
10%
10%
10%
50V
50V
50V
50V
50V
C351
C353
C354
C355
C356
1-136-967-11
1-136-497-81
1-126-791-11
1-126-960-11
1-126-961-11
FILM
FILM
ELECT
ELECT
ELECT
0.012uF
0.1uF
10uF
1uF
2.2uF
5%
5%
20%
20%
20%
100V
50V
35V
50V
50V
C359
C361
C364
1-126-947-11 ELECT
1-126-964-11 ELECT
1-162-966-11 CERAMIC CHIP
64
Remarks
47uF
20%
10uF
20%
0.0022uF 10%
35V
50V
50V
Ref. No.
Part No.
Description
Remarks
C370
C371
1-137-150-11 FILM
1-162-968-11 CERAMIC CHIP
0.01uF
5%
0.0047uF 10%
100V
50V
C372
C373
C374
C375
C376
1-162-964-11
1-162-964-11
1-126-947-11
1-162-963-11
1-162-963-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
0.001uF
0.001uF
47uF
680PF
680PF
10%
10%
20%
10%
10%
50V
50V
35V
50V
50V
C377
C378
C379
C380
C381
1-162-974-11
1-162-928-11
1-130-481-00
1-162-928-11
1-164-670-11
CERAMIC CHIP
CERAMIC CHIP
MYLAR
CERAMIC CHIP
CERAMIC CHIP
0.01uF
120PF
0.0068uF
120PF
1200PF
5%
5%
5%
5%
50V
50V
50V
50V
16V
C382
C383
C384
C385
C386
1-164-670-11
1-162-959-11
1-162-959-11
1-164-227-11
1-164-227-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
1200PF
330PF
330PF
0.022uF
0.022uF
5%
5%
5%
10%
10%
16V
50V
50V
25V
25V
C391
C405
C410
C411
C412
1-126-933-11
1-164-156-11
1-162-919-11
1-162-919-11
1-164-156-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100uF
0.1uF
22PF
22PF
0.1uF
20%
16V
25V
50V
50V
25V
C416
C419
C429
C430
C462
1-104-656-11
1-162-960-11
1-162-923-11
1-162-923-11
1-104-658-91
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
2200uF
220PF
47PF
47PF
100uF
20%
10%
5%
5%
20%
6.3V
50V
50V
50V
10V
C464
C497
C498
C499
C501
1-162-970-11
1-164-156-11
1-126-964-11
1-164-156-11
1-126-964-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
0.01uF
0.1uF
10uF
0.1uF
10uF
10%
25V
25V
50V
25V
50V
C502
C503
C520
C521
C522
1-136-497-81
1-136-497-81
1-164-156-11
1-162-960-11
1-162-960-11
FILM
FILM
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
220PF
220PF
5%
5%
C523
C524
C525
C534
C535
1-162-960-11
1-162-960-11
1-162-960-11
1-164-156-11
1-126-928-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
220PF
220PF
220PF
0.1uF
3300uF
C537
C538
C539
C540
C541
1-164-156-11
1-164-156-11
1-164-156-11
1-126-960-11
1-126-960-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
C542
C543
C544
C545
C546
1-126-960-11
1-126-960-11
1-126-960-11
1-126-960-11
1-162-960-11
C547
C550
C551
C552
C553
1-162-960-11
1-126-933-11
1-164-156-11
1-126-961-11
1-126-942-61
5%
5%
20%
20%
10%
10%
10%
10%
10%
50V
50V
25V
50V
50V
20%
50V
50V
50V
25V
10V
0.1uF
0.1uF
0.1uF
1uF
1uF
20%
20%
25V
25V
25V
50V
50V
ELECT
ELECT
ELECT
ELECT
CERAMIC CHIP
1uF
1uF
1uF
1uF
220PF
20%
20%
20%
20%
10%
50V
50V
50V
50V
50V
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
ELECT
220PF
100uF
0.1uF
2.2uF
1000uF
10%
20%
50V
16V
25V
50V
25V
20%
20%
HCD-LX10000
MAIN
Ref. No.
Part No.
Description
C560
C561
C562
C563
C564
1-130-483-00
1-130-483-00
1-126-933-11
1-126-925-91
1-100-566-91
MYLAR
MYLAR
ELECT
ELECT
CERAMIC CHIP
0.01uF
0.01uF
100uF
470uF
0.1uF
5%
5%
20%
20%
10%
Remarks
50V
50V
16V
10V
25V
C565
C566
C567
C568
C580
1-100-566-91
1-128-548-11
1-100-566-91
1-126-916-11
1-164-156-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
0.1uF
4700uF
0.1uF
1000uF
0.1uF
10%
20%
10%
20%
25V
25V
25V
6.3V
25V
C581
1-164-156-11 CERAMIC CHIP
0.1uF
Ref. No.
Part No.
Description
Remarks
< IC >
IC101
IC301
IC401
IC402
IC550
6-703-650-11
6-702-130-01
6-806-611-01
6-705-809-01
6-703-610-01
IC
IC
IC
IC
IC
M61529FP-D60G
HA12237F
M30622MEP-A77FPU0
BD4929G-TR
RT8H015C-T112-1
IC560
IC561
IC562
8-759-394-36 IC BA09T
6-703-550-01 IC TA7809LS
6-702-771-01 IC TA78033LS
25V
< JACK >
< CONNECTOR >
J101
CN100
CN402
CN501
* CN502
CN503
1-564-706-11
1-785-336-11
1-573-845-11
1-774-876-21
1-564-705-11
PIN, CONNECTOR (SMALL TYPE) 4P
PIN, CONNECTOR (LIGHT ANGLE) 10P
CONNECTOR, BOARD TO BOARD 13P
CONNECTOR, BOARD TO BOARD 8P
PIN, CONNECTOR (SMALL TYPE) 3P
CN505
CN506
* CN507
* CN508
* CN509
1-819-027-11
1-568-441-11
1-564-710-11
1-569-934-11
1-569-930-11
FFC/FPC CONNECTOR (ZIF) 27P
SOCKET, CONNECTOR 9P
PIN, CONNECTOR (SMALL TYPE) 8P
SOCKET, CONNECTOR 17P
SOCKET, CONNECTOR 13P
* CN510
CN580
1-568-449-11 HOUSING, CONNECTOR (PC BOARD) 3P
1-564-506-11 PLUG, CONNECTOR 3P
1-794-981-11 JACK, PIN 4P (AUDIO IN)
< JUMPER RESISTOR >
JR001
JR002
JR003
JR004
JR005
1-216-864-11
1-216-296-11
1-216-864-11
1-216-864-11
1-216-864-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
JR007
JR009
JR010
JR012
JR014
1-216-296-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
JR015
JR016
JR017
JR018
JR019
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
JR020
JR021
JR022
JR028
JR029
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
JR030
JR031
JR032
JR034
JR035
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
< FERRITE BEAD >
JR036
JR138
JR261
JR359
JR390
1-216-296-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
JR465
JR466
JR467
JR468
JR507
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
< DIODE >
D340
D341
D342
D401
D402
6-501-193-01
6-501-193-01
6-501-193-01
6-501-193-01
6-501-193-01
DIODE
DIODE
DIODE
DIODE
DIODE
1SS355WTE-17
1SS355WTE-17
1SS355WTE-17
1SS355WTE-17
1SS355WTE-17
D501
D502
D503
D504
D505
6-501-193-01
6-501-193-01
6-501-193-01
6-501-193-01
6-501-193-01
DIODE
DIODE
DIODE
DIODE
DIODE
1SS355WTE-17
1SS355WTE-17
1SS355WTE-17
1SS355WTE-17
1SS355WTE-17
D550
D560
D561
D562
D581
6-501-193-01
8-719-028-23
6-500-522-21
6-500-522-21
8-719-056-82
DIODE
DIODE
DIODE
DIODE
DIODE
1SS355WTE-17
D3SBA20-4101
10EDB40-TB3
10EDB40-TB3
UDZ-TE-17-6.2B
D583
8-719-056-83 DIODE UDZ-TE-17-6.8B
FB150
FB260
FB261
FB262
FB263
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
FB506
FB507
FB508
FB509
FB510
1-500-283-11
1-500-283-11
1-500-283-11
1-500-283-11
1-500-283-11
INDUCTOR, FERRITE BEAD
INDUCTOR, FERRITE BEAD
INDUCTOR, FERRITE BEAD
INDUCTOR, FERRITE BEAD
INDUCTOR, FERRITE BEAD
FB512
1-500-283-11 INDUCTOR, FERRITE BEAD
< COIL >
L302
L370
L371
L372
1-414-189-31
1-410-780-11
1-410-780-11
1-414-189-31
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
100uH
27mH
27mH
100uH
65
HCD-LX10000
MAIN
Ref. No.
Part No.
Description
Remarks
< TRANSISTOR >
Q101
Q151
Q180
Q181
Q250
8-729-120-28
8-729-120-28
8-729-802-80
8-729-802-80
8-729-802-80
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC1623-L5L6
2SC1623-L5L6
2SC3661
2SC3661
2SC3661
Q251
Q280
Q281
Q340
Q341
8-729-802-80
8-729-802-80
8-729-802-80
8-729-903-46
8-729-903-46
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC3661
2SC3661
2SC3661
2SB1132-P
2SB1132-P
Q342
Q343
Q344
Q345
Q370
8-729-903-46
8-729-027-43
8-729-027-43
8-729-027-43
8-729-141-75
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SB1132-P
DTC114EKA-T146
DTC114EKA-T146
DTC114EKA-T146
2SD596DV345
Q371
Q372
Q373
Q374
Q375
8-729-802-80
8-729-802-80
8-729-802-80
8-729-802-80
8-729-802-80
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC3661
2SC3661
2SC3661
2SC3661
2SC3661
Q376
Q377
Q378
Q379
Q380
8-729-802-80
6-550-580-01
6-550-185-01
8-729-027-43
8-729-027-43
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC3661
2SA1235TP-1F
RT1P137P-TP-1
DTC114EKA-T146
DTC114EKA-T146
Q381
Q382
Q383
Q501
Q504
8-729-027-43
8-729-027-23
8-729-027-43
8-729-901-00
8-729-027-23
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTC114EKA-T146
DTA114EKA-T146
DTC114EKA-T146
DTC124EK
DTA114EKA-T146
Q505
Q540
Q541
Q542
Q543
8-729-901-00
8-729-027-31
8-729-027-43
8-729-027-31
8-729-027-43
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTC124EK
DTA124EKA-T146
DTC114EKA-T146
DTA124EKA-T146
DTC114EKA-T146
Q544
Q545
Q560
Q561
Q580
8-729-027-31
8-729-027-43
6-550-185-01
8-729-027-43
8-729-120-28
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTA124EKA-T146
DTC114EKA-T146
RT1P137P-TP-1
DTC114EKA-T146
2SC1623-L5L6
Q582
Q583
Q584
Q585
8-729-120-28
8-729-027-31
8-729-027-43
8-729-026-68
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC1623-L5L6
DTA124EKA-T146
DTC114EKA-T146
2SD2525 (TP)
< RESISTOR >
R101
R102
R103
R104
R105
1-216-825-11
1-216-833-11
1-216-818-11
1-216-821-11
1-216-841-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
10K
560
1K
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R106
R107
R116
R121
R122
1-216-833-11
1-216-813-11
1-216-809-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
220
100
10K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
66
Ref. No.
Part No.
Description
R130
R131
R132
R133
R140
1-216-825-11
1-216-825-11
1-216-857-11
1-216-845-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
2.2K
1M
100K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
Remarks
R150
R151
R152
R153
R154
1-216-809-11
1-216-825-11
1-216-833-11
1-216-818-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
2.2K
10K
560
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R155
R156
R157
R166
R180
1-216-841-11
1-216-833-11
1-216-813-11
1-216-809-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
10K
220
100
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R181
R182
R183
R184
R185
1-216-833-11
1-216-841-11
1-216-841-11
1-216-821-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
47K
47K
1K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R186
R187
R250
R251
R252
1-216-833-11
1-216-833-11
1-216-821-11
1-216-833-11
1-216-839-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10K
1K
10K
33K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R253
R254
R255
R256
R257
1-216-833-11
1-216-833-11
1-216-833-11
1-216-839-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10K
10K
33K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R260
R261
R262
R263
R264
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-845-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
METAL CHIP
0
0
0
0
100K
5%
1/10W
R265
R266
R267
R268
R269
1-216-845-11
1-216-845-11
1-216-845-11
1-216-821-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
100K
100K
1K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R270
R271
R272
R273
R274
1-216-821-11
1-216-821-11
1-216-837-11
1-216-833-11
1-216-841-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
22K
10K
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R281
R282
R285
R286
R290
1-216-833-11
1-216-839-11
1-216-833-11
1-216-839-11
1-216-841-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
33K
10K
33K
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R291
R292
R293
R294
R295
1-216-829-11
1-216-841-11
1-216-841-11
1-216-829-11
1-216-841-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
47K
47K
4.7K
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R296
R297
R301
1-216-829-11 METAL CHIP
1-216-841-11 METAL CHIP
1-216-827-11 METAL CHIP
4.7K
47K
3.3K
5%
5%
5%
1/10W
1/10W
1/10W
HCD-LX10000
MAIN
Ref. No.
Part No.
Description
Remarks
R302
R303
1-216-829-11 METAL CHIP
1-216-833-11 METAL CHIP
4.7K
10K
5%
5%
1/10W
1/10W
R304
R305
R306
R307
R308
1-216-825-11
1-216-841-11
1-216-837-11
1-216-857-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
47K
22K
1M
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R309
R310
R311
R312
R319
1-216-829-11
1-216-809-11
1-216-864-11
1-216-809-11
1-216-825-11
METAL CHIP
METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
4.7K
100
0
100
2.2K
5%
5%
1/10W
1/10W
5%
5%
1/10W
1/10W
R336
R337
R339
R340
R341
1-218-867-11
1-216-833-11
1-216-837-11
1-216-825-11
1-216-827-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
6.8K
10K
22K
2.2K
3.3K
0.5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R342
R343
R344
R345
R346
1-216-825-11
1-216-825-11
1-216-819-11
1-216-827-11
1-216-819-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
2.2K
680
3.3K
680
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R347
R348
R349
R351
R352
1-216-825-11
1-216-819-11
1-216-827-11
1-216-827-11
1-216-829-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
680
3.3K
3.3K
4.7K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R353
R354
R355
R356
R357
1-216-833-11
1-216-825-11
1-216-841-11
1-218-867-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
2.2K
47K
6.8K
10K
5%
5%
5%
0.5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R369
R370
R371
R372
R373
1-216-825-11
1-216-827-11
1-216-829-11
1-216-833-11
1-216-829-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
3.3K
4.7K
10K
4.7K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R374
R375
R376
R377
R378
1-216-829-11
1-216-833-11
1-216-829-11
1-216-805-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
10K
4.7K
47
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R379
R380
R381
R382
R383
1-216-797-11
1-218-867-11
1-216-825-11
1-216-825-11
1-216-825-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10
6.8K
2.2K
2.2K
2.2K
5%
0.5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R384
R385
R386
R387
R388
1-216-825-11
1-216-825-11
1-216-803-11
1-216-825-11
1-218-867-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
2.2K
33
2.2K
6.8K
5%
5%
5%
5%
0.5%
1/10W
1/10W
1/10W
1/10W
1/10W
R389
R390
R391
R392
R393
1-216-837-11
1-216-833-11
1-216-833-11
1-216-833-11
1-216-825-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
22K
10K
10K
10K
2.2K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
Ref. No.
Part No.
Description
R394
R395
R396
R397
R399
1-216-829-11
1-216-841-11
1-216-833-11
1-216-825-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
47K
10K
2.2K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
Remarks
R400
R401
R402
R403
R404
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R405
R406
R407
R409
R411
1-216-809-11
1-216-809-11
1-216-809-11
1-216-833-11
1-216-851-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
10K
330K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R412
R413
R417
R418
R419
1-216-845-11
1-216-864-11
1-216-833-11
1-216-813-11
1-216-809-11
METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
0
10K
220
100
5%
1/10W
5%
5%
5%
1/10W
1/10W
1/10W
R420
R421
R422
R423
R424
1-216-821-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
100
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R425
R426
R427
R428
R429
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R430
R431
R432
R433
R434
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R438
R439
R440
R441
R442
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R443
R444
R445
R446
R447
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R448
R451
R452
R463
R469
1-216-809-11
1-216-809-11
1-216-809-11
1-216-833-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
10K
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R470
R472
R475
R476
R477
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R478
R484
R485
1-216-809-11 METAL CHIP
1-216-809-11 METAL CHIP
1-216-809-11 METAL CHIP
100
100
100
5%
5%
5%
1/10W
1/10W
1/10W
67
HCD-LX10000
MAIN
Ref. No.
MIC
Part No.
Description
Remarks
R486
R487
1-216-809-11 METAL CHIP
1-216-809-11 METAL CHIP
100
100
5%
5%
1/10W
1/10W
R488
R489
R490
R492
R493
1-216-809-11
1-216-809-11
1-216-809-11
1-216-815-11
1-216-829-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
330
4.7K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R500
R501
R502
R503
R505
1-216-833-11
1-216-813-11
1-216-821-11
1-216-864-11
1-216-829-11
METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
METAL CHIP
10K
220
1K
0
4.7K
5%
5%
5%
1/10W
1/10W
1/10W
5%
1/10W
R529
R530
R532
R538
R540
1-216-833-11
1-216-833-11
1-216-864-11
1-216-833-11
1-216-843-11
METAL CHIP
METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
10K
10K
0
10K
68K
5%
5%
1/10W
1/10W
5%
5%
1/10W
1/10W
R541
R542
R543
R544
R545
1-216-835-11
1-216-853-11
1-216-843-11
1-216-835-11
1-216-853-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
15K
470K
68K
15K
470K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R546
R547
R548
R560
R562
1-216-843-11
1-216-835-11
1-216-853-11
1-216-826-11
1-216-825-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
68K
15K
470K
2.7K
2.2K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R563
R570
R571
R573
R574
1-216-825-11
1-216-833-11
1-216-833-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
10K
10K
10K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R575
R577
R579
R580
R582
1-216-821-11
1-216-845-11
1-216-833-11
1-216-833-11
1-216-864-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
1K
100K
10K
10K
0
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
R585
R586
R587
R591
R592
1-216-833-11
1-216-833-11
1-216-833-11
1-216-835-11
1-216-829-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10K
10K
15K
4.7K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R593
1-216-825-11 METAL CHIP
2.2K
5%
1/10W
Ref. No.
Part No.
Description
C1101
C1102
C1103
C1104
1-162-970-11
1-124-257-00
1-162-923-11
1-115-416-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
0.01uF
2.2uF
47PF
0.001uF
10%
20%
5%
5%
25V
50V
50V
25V
Remarks
C1105
C1106
C1108
C1109
C1110
1-162-962-11
1-124-257-00
1-124-257-00
1-162-923-11
1-164-217-11
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
470PF
2.2uF
2.2uF
47PF
150PF
10%
20%
20%
5%
5%
50V
50V
50V
50V
50V
C1111
C1112
C1113
C1114
C1115
1-162-923-11
1-124-261-00
1-124-261-00
1-124-464-11
1-126-961-11
CERAMIC CHIP
ELECT
ELECT
ELECT
ELECT
47PF
10uF
10uF
0.22uF
2.2uF
5%
20%
20%
20%
20%
50V
50V
50V
50V
50V
C1116
C1117
C1118
C1119
C1120
1-164-227-11
1-126-960-11
1-162-969-11
1-162-965-11
1-136-495-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
FILM
0.022uF
1uF
0.0068uF
0.0015uF
0.068uF
10%
20%
10%
10%
5%
25V
50V
25V
50V
50V
C1121
C1122
C1123
C1124
C1125
1-124-589-11
1-124-589-11
1-136-495-11
1-126-960-11
1-162-965-11
ELECT
ELECT
FILM
ELECT
CERAMIC CHIP
47uF
47uF
0.068uF
1uF
0.0015uF
20%
20%
5%
20%
10%
16V
16V
50V
50V
50V
C1126
C1127
C1128
C1129
C1130
1-162-969-11
1-136-495-11
1-126-957-11
1-126-957-11
1-136-155-00
CERAMIC CHIP
FILM
ELECT
ELECT
FILM
0.0068uF
0.068uF
0.22uF
0.22uF
0.015uF
10%
5%
20%
20%
5%
25V
50V
50V
50V
50V
C1131
C1133
C1139
C1142
1-126-176-11
1-113-619-11
1-126-160-11
1-216-864-11
ELECT
CERAMIC CHIP
ELECT
SHORT CHIP
220uF
0.47uF
1uF
0
20%
10V
10V
50V
20%
< CONNECTOR >
CN1102 1-785-329-11 PIN, CONNECTOR (LIGHT ANGLE) 3P
< DIODE >
D1100
D1101
D1102
6-501-193-01 DIODE 1SS355WTE-17
6-501-193-01 DIODE 1SS355WTE-17
8-719-976-99 DIODE DTZ5.1B
< FERRITE BEAD >
FB1100 1-216-864-11 SHORT CHIP
FB1101 1-216-864-11 SHORT CHIP
< TRANSFORMER >
T301
< IC >
1-433-372-11 TRANSFORMER, BIAS OSCILLATION
IC1100
IC1101
< VIBRATOR >
X401
1-760-252-12 VIBRATOR, CRYSTAL (32.768kHz)
X402
1-795-482-11 VIBRATOR, CERAMIC (16MHz)
*************************************************************
68
1-817-629-11 JACK (LARGE TYPE) (MIC 1)
1-817-629-11 JACK (LARGE TYPE) (MIC 2)
1-794-702-11 JACK, HEADPHONE (PHONES)
< JUMPER RESISTOR >
< CAPACITOR >
1-162-970-11 CERAMIC CHIP
8-759-710-97 IC NJM4565M-D
8-759-496-41 IC M65850FP-E1
< JACK >
J1100
J1101
J1103
A-1089-466-A MIC BOARD, COMPLETE
*******************
C1100
0
0
0.01uF
10%
25V
JR1101 1-216-864-11 SHORT CHIP
0
HCD-LX10000
Ref. No.
Part No.
Description
JR1102
JR1103
JR1104
JR1105
1-216-864-11
1-216-296-11
1-216-296-11
1-216-296-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
Remarks
JR1106
JR1108
JR1113
JR1114
1-216-864-11
1-216-864-11
1-216-296-11
1-216-296-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
Ref. No.
MIC
MOTOR (LD)
Part No.
Description
MOTOR (TB)
PA
Remarks
< CAPACITOR >
< RESISTOR >
R1100
R1101
R1102
R1103
R1104
1-216-833-11
1-216-821-11
1-216-833-11
1-216-821-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
1K
10K
1K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R1105
R1106
R1107
R1108
R1109
1-216-821-11
1-216-841-11
1-216-809-11
1-216-833-11
1-216-847-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
47K
100
10K
150K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R1110
R1111
R1113
R1114
R1115
1-216-809-11
1-216-845-11
1-216-835-11
1-216-835-11
1-216-815-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100K
15K
15K
330
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R1116
R1117
R1118
R1119
R1120
1-216-815-11
1-216-835-11
1-216-835-11
1-216-835-11
1-216-846-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
330
15K
15K
15K
120K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R1121
R1122
R1123
R1124
R1125
1-216-835-11
1-216-835-11
1-216-835-11
1-216-841-11
1-216-825-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
15K
15K
15K
47K
2.2K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R1126
R1132
1-216-825-11 METAL CHIP
1-216-864-11 SHORT CHIP
2.2K
0
5%
1/10W
C600
C601
C602
C604
C605
1-126-963-11
1-162-966-11
1-104-658-91
1-162-960-11
1-131-992-91
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
4.7uF
0.0022uF
100uF
220PF
100000PF
20%
10%
20%
10%
50V
50V
10V
50V
35V
C608
C609
C610
C616
C617
1-126-965-91
1-128-560-11
1-128-560-11
1-136-495-11
1-136-495-11
ELECT
ELECT
ELECT
FILM
FILM
22uF
22uF
22uF
0.068uF
0.068uF
20%
20%
20%
5%
5%
50V
100V
100V
50V
50V
C618
C619
C634
C635
C636
1-128-582-11
1-128-582-11
1-104-665-11
1-104-665-11
1-107-721-11
ELECT
ELECT
ELECT
ELECT
ELECT
10uF
10uF
100uF
100uF
4.7uF
20%
20%
20%
20%
20%
100V
100V
25V
25V
100V
C637
C648
C649
C650
C651
1-107-721-11
1-104-658-91
1-126-964-11
1-126-963-11
1-162-966-11
ELECT
ELECT
ELECT
ELECT
CERAMIC CHIP
4.7uF
100uF
10uF
4.7uF
0.0022uF
20%
20%
20%
20%
10%
100V
10V
50V
50V
50V
C652
C654
C655
C656
C658
1-104-658-91
1-162-960-11
1-126-964-11
1-127-815-11
1-127-811-11
ELECT
CERAMIC CHIP
ELECT
ELECT
ELECT
100uF
220PF
10uF
3300uF
3300uF
20%
10%
20%
20%
20%
10V
50V
50V
100V
50V
C660
C666
C667
C676
C678
1-131-992-91
1-136-495-11
1-136-495-11
1-127-815-11
1-127-811-11
CERAMIC CHIP
FILM
FILM
ELECT
ELECT
100000PF
0.068uF
0.068uF
3300uF
3300uF
5%
5%
20%
20%
35V
50V
50V
100V
50V
C681
C682
C683
C691
C692
1-110-563-11
1-110-563-11
1-131-992-91
1-110-563-11
1-110-563-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.068uF
0.068uF
100000PF
0.068uF
0.068uF
C693
1-131-992-91 CERAMIC CHIP
100000PF
10%
10%
10%
10%
16V
16V
35V
16V
16V
35V
< VARIABLE RESISTOR >
< CONNECTOR >
RV1100 1-227-452-11 RES, VAR, CARBON 50K (MIC LEVEL)
RV1101 1-227-452-11 RES, VAR, CARBON 50K (ECHO LEVEL)
*************************************************************
CN600
CN601
1-764-865-41 CONNECTOR, BOARD TO BOARD 13P
1-784-031-41 CONNECTOR, BOARD TO BOARD 8P
< DIODE >
1-687-133-12 MOTOR (LD) BOARD
*****************
*************************************************************
1-687-134-12 MOTOR (TB) BOARD
*****************
< CONNECTOR >
CN742 1-784-727-11 CONNECTOR, FFC 5P
*************************************************************
A-1089-586-A PA BOARD, COMPLETE
******************
D609
D611
D612
D620
D624
6-501-193-01
8-719-056-93
8-719-056-93
6-501-193-01
6-501-193-01
DIODE
DIODE
DIODE
DIODE
DIODE
1SS355WTE-17
UDZ-TE-17-18B
UDZ-TE-17-18B
1SS355WTE-17
1SS355WTE-17
D646
D654
D655
D656
D658
6-501-193-01
6-501-193-01
6-501-193-01
8-719-500-60
8-719-500-60
DIODE
DIODE
DIODE
DIODE
DIODE
1SS355WTE-17
1SS355WTE-17
1SS355WTE-17
D5SBA20
D5SBA20
D660
D661
D665
D670
6-501-193-01
6-501-193-01
6-501-193-01
6-501-193-01
DIODE
DIODE
DIODE
DIODE
1SS355WTE-17
1SS355WTE-17
1SS355WTE-17
1SS355WTE-17
69
HCD-LX10000
PA
Ref. No.
Part No.
Description
Remarks
< IC >
IC600
8-749-017-06 IC STK412-150
< JUMPER RESISTOR >
JR600
JR603
1-216-296-11 SHORT CHIP
1-216-296-11 SHORT CHIP
0
0
< TRANSISTOR >
Q604
Q606
Q610
Q618
Q628
8-729-924-99
8-729-821-00
8-729-924-99
8-729-924-99
8-729-120-28
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC3722K-E
2SA1207
2SC3722K-E
2SC3722K-E
2SC1623-L5L6
Q629
Q630
Q634
Q640
Q641
8-729-120-28
8-729-120-28
8-729-027-31
8-729-802-80
8-729-802-80
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC1623-L5L6
2SC1623-L5L6
DTA124EKA-T146
2SC3661
2SC3661
Q644
Q647
Q648
Q666
Q668
8-729-120-28
8-729-120-28
8-729-120-28
8-729-120-28
8-729-924-99
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC1623-L5L6
2SC1623-L5L6
2SC1623-L5L6
2SC1623-L5L6
2SC3722K-E
Q682
8-729-120-28 TRANSISTOR 2SC1623-L5L6
< RESISTOR >
R600
R601
R602
R603
R604
1-216-821-11
1-216-841-11
1-216-817-11
1-216-841-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
47K
470
47K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R605
R606
R607
R608
R609
1-216-833-11
1-216-841-11
1-216-825-11
1-216-845-11
1-216-843-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
47K
2.2K
100K
68K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R610
R611
0R612
R613
R614
1-216-843-11
1-216-839-11
1-245-605-51
1-215-872-11
1-215-872-11
METAL CHIP
METAL CHIP
FUSIBLE
METAL OXIDE
METAL OXIDE
68K
33K
100
3.3K
3.3K
5%
5%
5%
5%
5%
1/10W
1/10W
1/4W
1W
1W
0R615
0R616
R617
0R618
R619
1-245-605-51
1-217-637-00
1-216-845-11
1-234-798-11
1-216-821-11
FUSIBLE
100
5%
FUSIBLE
1
5%
METAL CHIP
100K
5%
ENCAPSULATED COMPONENT
METAL CHIP
1K
5%
1/4W
1/4W
1/10W
R620
R621
R622
R623
R624
1-216-839-11
1-216-845-11
1-245-711-31
1-216-843-11
1-216-837-11
METAL CHIP
METAL CHIP
CARBON
METAL CHIP
METAL CHIP
33K
100K
10
68K
22K
5%
5%
5%
5%
5%
1/10W
1/10W
1/2W
1/10W
1/10W
R625
R626
R627
R628
R629
1-216-826-11
1-216-842-11
1-216-821-11
1-216-837-11
1-216-830-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.7K
56K
1K
22K
5.6K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
70
1/10W
Ref. No.
Part No.
Description
R630
R631
R632
R633
R634
1-216-845-11
1-216-845-11
1-216-845-11
1-216-842-11
1-216-825-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
100K
100K
56K
2.2K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
Remarks
R635
R636
R637
R638
R639
1-216-833-11
1-215-891-11
1-215-891-11
1-216-845-11
1-216-845-11
METAL CHIP
METAL OXIDE
METAL OXIDE
METAL CHIP
METAL CHIP
10K
680
680
100K
100K
5%
5%
5%
5%
5%
1/10W
2W
2W
1/10W
1/10W
R640
R641
R642
R643
R644
1-216-821-11
1-216-821-11
1-216-811-11
1-216-811-11
1-216-825-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
150
150
2.2K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R645
0R646
R647
R648
R649
1-216-833-11
1-260-086-31
1-216-829-11
1-216-829-11
1-216-837-11
METAL CHIP
CARBON
METAL CHIP
METAL CHIP
METAL CHIP
10K
82
4.7K
4.7K
22K
5%
5%
5%
5%
5%
1/10W
1/2W
1/10W
1/10W
1/10W
R650
R651
R652
R653
R654
1-216-821-11
1-216-841-11
1-216-817-11
1-216-841-11
1-216-841-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
47K
470
47K
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R655
R656
R657
R658
R660
1-216-841-11
1-216-849-11
1-216-849-11
1-216-845-11
1-216-837-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
220K
220K
100K
22K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R661
R662
R663
0R665
R666
1-216-837-11
1-216-811-11
1-216-811-11
1-260-086-31
1-216-829-11
METAL CHIP
METAL CHIP
METAL CHIP
CARBON
METAL CHIP
22K
150
150
82
4.7K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/2W
1/10W
R667
0R668
R669
R670
R671
1-216-833-11
1-234-798-11
1-216-821-11
1-216-839-11
1-216-845-11
METAL CHIP
10K
5%
ENCAPSULATED COMPONENT
METAL CHIP
1K
5%
METAL CHIP
33K
5%
METAL CHIP
100K
5%
1/10W
1/10W
1/10W
1/10W
R672
R673
R674
R676
R677
1-245-711-31
1-216-842-11
1-216-837-11
1-216-849-11
1-216-849-11
CARBON
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10
56K
22K
220K
220K
5%
5%
5%
5%
5%
1/2W
1/10W
1/10W
1/10W
1/10W
R678
R681
R682
R683
R685
1-216-845-11
1-245-711-31
1-216-821-11
1-216-829-11
1-216-833-11
METAL CHIP
CARBON
METAL CHIP
METAL CHIP
METAL CHIP
100K
10
1K
4.7K
10K
5%
5%
5%
5%
5%
1/10W
1/2W
1/10W
1/10W
1/10W
R691
R692
R693
R694
R695
1-245-711-31
1-216-841-11
1-216-845-11
1-216-843-11
1-216-845-11
CARBON
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10
47K
100K
68K
100K
5%
5%
5%
5%
5%
1/2W
1/10W
1/10W
1/10W
1/10W
R696
R697
R698
1-216-845-11 METAL CHIP
1-216-825-11 METAL CHIP
1-216-845-11 METAL CHIP
100K
2.2K
100K
5%
5%
5%
1/10W
1/10W
1/10W
HCD-LX10000
PA
Ref. No.
Part No.
Description
Remarks
< RELAY >
RY646
RY665
1-755-500-11 RELAY
1-755-500-11 RELAY
< THERMISTOR >
TH629
TH630
1-807-796-11 THERMISTOR
1-807-796-11 THERMISTOR
< TERMINAL >
TM600
1-780-001-21 TERMINAL BOARD (SPEAKER)
(FRONT SPEAKER)
TM601 1-780-001-21 TERMINAL BOARD (SPEAKER)
(SURR SPEAKER)
*************************************************************
A-1089-463-A PANEL BOARD, COMPLETE
**********************
< CAPACITOR >
C900
C901
C902
C903
C904
1-126-163-11
1-164-230-11
1-164-230-11
1-164-156-11
1-164-156-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
4.7uF
220PF
220PF
0.1uF
0.1uF
C905
C906
C907
C908
C909
1-164-156-11
1-162-964-11
1-162-964-11
1-164-230-11
1-164-230-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.001uF
0.001uF
220PF
220PF
C910
C916
C917
C918
C919
1-164-156-11
1-164-156-11
1-164-156-11
1-119-941-91
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
C922
C923
C924
C925
C926
1-124-261-00
1-162-970-11
1-162-927-11
1-162-927-11
1-162-927-11
C927
C928
C929
C930
C931
20%
5%
5%
50V
50V
50V
25V
25V
10%
10%
5%
5%
25V
50V
50V
50V
50V
0.1uF
0.1uF
0.1uF
470uF
0.01uF
20%
10%
25V
25V
25V
6.3V
25V
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
10uF
0.01uF
100PF
100PF
100PF
20%
10%
5%
5%
5%
50V
25V
50V
50V
50V
1-162-927-11
1-162-927-11
1-162-927-11
1-162-927-11
1-162-927-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100PF
100PF
100PF
100PF
100PF
5%
5%
5%
5%
5%
50V
50V
50V
50V
50V
C932
C933
C934
C935
C936
1-162-927-11
1-164-315-11
1-162-927-11
1-162-927-11
1-162-927-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100PF
470PF
100PF
100PF
100PF
5%
5%
5%
5%
5%
50V
50V
50V
50V
50V
C937
C938
C939
C941
C942
1-162-927-11
1-162-927-11
1-162-964-11
1-124-261-00
1-124-261-00
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
100PF
100PF
0.001uF
10uF
10uF
5%
5%
10%
20%
20%
50V
50V
50V
50V
50V
C944
C945
C946
1-124-261-00 ELECT
1-125-837-91 CERAMIC CHIP
1-164-315-11 CERAMIC CHIP
10uF
1uF
470PF
20%
10%
5%
50V
6.3V
50V
Ref. No.
Part No.
Description
PANEL
Remarks
C947
C948
1-125-837-91 CERAMIC CHIP
1-164-315-11 CERAMIC CHIP
1uF
470PF
10%
5%
6.3V
50V
C949
C950
C951
C952
C953
1-125-837-91
1-162-968-11
1-125-837-91
1-162-968-11
1-125-837-91
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
1uF
0.0047uF
1uF
0.0047uF
1uF
10%
10%
10%
10%
10%
6.3V
50V
6.3V
50V
6.3V
C954
C955
C956
C957
C958
1-164-227-11
1-125-837-91
1-164-227-11
1-125-837-91
1-165-176-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.022uF
1uF
0.022uF
1uF
0.047uF
10%
10%
10%
10%
10%
25V
6.3V
25V
6.3V
16V
C959
C961
C966
C970
C971
1-165-176-11
1-164-156-11
1-164-156-11
1-119-941-91
1-119-941-91
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
0.047uF
0.1uF
0.1uF
470uF
470uF
10%
20%
20%
16V
25V
25V
6.3V
6.3V
C972
C973
C977
C978
C979
1-162-927-11
1-162-927-11
1-162-927-11
1-162-927-11
1-162-927-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100PF
100PF
100PF
100PF
100PF
5%
5%
5%
5%
5%
50V
50V
50V
50V
50V
C980
C981
C982
C983
1-162-927-11
1-162-927-11
1-162-927-11
1-162-927-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100PF
100PF
100PF
100PF
5%
5%
5%
5%
50V
50V
50V
50V
< CONNECTOR >
* CN902 1-569-934-11 SOCKET, CONNECTOR 17P
CNS902 1-819-074-11 BOARD TO BOARD HEADER (8P)
< DIODE >
D901
D902
D903
D904
D905
6-501-193-01
6-501-228-01
6-500-522-21
6-500-522-21
8-719-056-83
DIODE
DIODE
DIODE
DIODE
DIODE
1SS355WTE-17
SELU5420E-STP15 (?/1)
10EDB40-TB3
10EDB40-TB3
UDZ-TE-17-6.8B
D906
D907
D908
D909
D910
6-501-227-01
6-501-228-01
6-501-227-01
6-501-228-01
6-501-227-01
DIODE
DIODE
DIODE
DIODE
DIODE
SELU5620S-STP15 (CD)
SELU5420E-STP15 (CD)
SELU5620S-STP15 (TUNER/BAND)
SELU5420E-STP15 (TUNER/BAND)
SELU5620S-STP15 (TAPE A/B)
D911
D912
D913
D914
D915
6-501-227-01
6-501-227-01
6-501-227-01
6-501-227-01
6-501-228-01
DIODE
DIODE
DIODE
DIODE
DIODE
SELU5620S-STP15 (bB)
SELU5620S-STP15 (X/x)
SELU5620S-STP15 (TUNIMG+ >)
SELU5620S-STP15 (ALBUM+ M)
SELU5420E-STP15 (bB)
D916
D917
D918
D925
D926
6-501-228-01
6-501-227-01
6-501-228-01
6-501-227-01
6-501-228-01
DIODE
DIODE
DIODE
DIODE
DIODE
SELU5420E-STP15 (TAPE A/B)
SELU5620S-STP15 (TV)
SELU5420E-STP15 (TV)
SELU5620S-STP15 (VIDEO/MD)
SELU5420E-STP15 (VIDEO/MD)
D927
D928
D929
D930
6-501-227-01
6-501-227-01
6-501-227-01
6-501-227-01
DIODE
DIODE
DIODE
DIODE
SELU5620S-STP15 (?/1)
SELU5620S-STP15 (X)
SELU5620S-STP15 (TUNING- .)
SELU5620S-STP15 (ALBUM- m)
71
HCD-LX10000
PANEL
Ref. No.
Part No.
Description
Remarks
Ref. No.
Part No.
Description
Remarks
R910
R911
R912
R914
R915
1-216-821-11
1-216-821-11
1-216-809-11
1-216-821-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
100
1K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R917
R918
R919
R920
R922
1-216-845-11
1-216-845-11
1-216-845-11
1-216-833-11
1-216-857-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
100K
100K
10K
1M
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R933
R939
R940
R941
R942
1-216-821-11
1-216-821-11
1-216-833-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
10K
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R943
R944
R945
R946
R947
1-216-821-11
1-216-805-11
1-216-839-11
1-216-842-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
47
33K
56K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R948
R949
R950
R951
R952
1-218-867-11
1-216-821-11
1-216-821-11
1-216-830-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
6.8K
1K
1K
5.6K
1K
0.5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R953
R954
R956
R957
R958
1-216-821-11
1-216-833-11
1-216-826-11
1-216-821-11
1-216-817-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
10K
2.7K
1K
470
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R959
R960
R961
R962
R963
1-216-819-11
1-216-821-11
1-216-823-11
1-216-823-11
1-216-825-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
680
1K
1.5K
1.5K
2.2K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R964
R965
R966
R967
R968
1-216-827-11
1-216-829-11
1-218-867-11
1-216-833-11
1-216-835-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
3.3K
4.7K
6.8K
10K
15K
5%
5%
0.5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R969
R970
R971
R972
R973
1-216-819-11
1-218-867-11
1-216-821-11
1-216-819-11
1-216-819-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
680
6.8K
1K
680
680
5%
0.5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R974
R975
R977
R978
R980
1-216-819-11
1-216-817-11
1-216-821-11
1-216-817-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
680
470
1K
470
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R981
R982
R983
R984
R985
1-216-819-11
1-216-819-11
1-216-819-11
1-216-819-11
1-216-819-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
680
680
680
680
680
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R986
1-216-819-11 METAL CHIP
680
5%
1/10W
< FERRITE BEAD >
FB901
1-216-864-11 SHORT CHIP
0
< FLUORESCENT INDICATOR >
FL901
1-519-794-21 VACUUM FLUORESCENT DISPLAYS
< IC >
IC902
IC903
IC904
6-805-078-01 IC MB90M407PF-G-144E1
6-600-210-01 IC RPM7240-H8 (g)
6-705-678-01 IC NJM2760V-TE2
< JUMPER RESISTOR >
JR909
JR910
JR911
JR912
JR913
1-216-864-11
1-216-864-11
1-216-864-11
1-216-296-11
1-216-864-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
JR914
JR915
JR916
JR917
JR918
1-216-864-11
1-216-809-11
1-216-864-11
1-216-864-11
1-216-864-11
SHORT CHIP
METAL CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
100
0
0
0
JR921
JR922
1-216-296-11 SHORT CHIP
1-216-296-11 SHORT CHIP
5%
1/10W
0
0
< TRANSISTOR >
Q900
Q901
Q902
Q903
Q904
8-729-027-23
8-729-027-56
8-729-027-56
8-729-027-23
8-729-106-60
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTA114EKA-T146
DTC143TKA-T146
DTC143TKA-T146
DTA114EKA-T146
2SB1115A-YQ
Q905
Q906
Q907
Q908
Q909
8-729-106-60
8-729-027-43
8-729-027-43
8-729-027-43
8-729-027-43
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SB1115A-YQ
DTC114EKA-T146
DTC114EKA-T146
DTC114EKA-T146
DTC114EKA-T146
Q910
Q914
Q915
Q916
Q917
8-729-027-43
8-729-027-56
8-729-027-43
8-729-027-43
8-729-027-43
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTC114EKA-T146
DTC143TKA-T146
DTC114EKA-T146
DTC114EKA-T146
DTC114EKA-T146
Q918
Q919
Q920
8-729-027-43 TRANSISTOR DTC114EKA-T146
8-729-027-43 TRANSISTOR DTC114EKA-T146
8-729-027-43 TRANSISTOR DTC114EKA-T146
< RESISTOR >
R900
R901
R902
R903
R904
1-216-833-11
1-216-833-11
1-216-833-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10K
10K
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R905
R906
R907
R908
R909
1-216-835-11
1-216-835-11
1-216-835-11
1-216-809-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
15K
15K
15K
100
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
72
HCD-LX10000
PANEL
Ref. No.
Part No.
Description
R987
R988
R989
R990
1-216-819-11
1-216-819-11
1-216-819-11
1-216-819-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
680
680
680
680
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
Remarks
R991
R992
R993
R994
R995
1-216-819-11
1-216-819-11
1-216-819-11
1-216-819-11
1-216-819-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
680
680
680
680
680
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R996
R997
R999
R1135
R1136
1-216-819-11
1-216-819-11
1-216-864-11
1-216-819-11
1-216-819-11
METAL CHIP
METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
680
680
0
680
680
5%
5%
1/10W
1/10W
5%
5%
1/10W
1/10W
R1137
R1141
R1142
R1147
R1148
1-216-819-11
1-216-821-11
1-216-821-11
1-216-821-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
680
1K
1K
1K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R1160
R1161
R1162
R1163
R1164
1-218-867-11
1-216-833-11
1-218-867-11
1-216-823-11
1-216-825-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
6.8K
10K
6.8K
1.5K
2.2K
0.5%
5%
0.5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R1165
R1166
R1167
R1175
R1176
1-216-827-11
1-216-829-11
1-216-814-11
1-216-817-11
1-216-819-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
3.3K
4.7K
270
470
680
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R1177
R1178
R1179
R1180
R1183
1-216-821-11
1-216-823-11
1-216-821-11
1-216-814-11
1-216-808-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1.5K
1K
270
82
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R1186
R1187
R1188
R1189
R1194
1-216-829-11
1-216-833-11
1-216-821-11
1-216-801-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
10K
1K
22
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R1195
R1197
R1198
1-216-821-11 METAL CHIP
1-216-821-11 METAL CHIP
1-216-821-11 METAL CHIP
1K
1K
1K
5%
5%
5%
1/10W
1/10W
1/10W
Ref. No.
Part No.
PRIMARY
SENSOR
Description
Remarks
S917
S918
S919
1-771-963-11 SWITCH, ROTARY (ALBUM)
1-762-875-21 SWITCH, KEYBOARD (TAPE A/B)
1-762-875-21 SWITCH, KEYBOARD (TUNER/BAND)
S920
S925
S927
S928
S929
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
SWITCH, KEYBOARD (CD)
SWITCH, KEYBOARD (?/1)
SWITCH, KEYBOARD (AMP MENU)
SWITCH, KEYBOARD (ILLUMINATION)
SWITCH, KEYBOARD (SURR SPEAKER MODE)
S930
S931
S932
S970
1-762-875-21
1-762-875-21
1-762-875-21
1-418-725-51
SWITCH, KEYBOARD (GROOVE)
SWITCH, KEYBOARD (SOUND FLASH)
SWITCH, KEYBOARD (ENTER)
ENCODER, ROTARY (12 TYPE) (VOLUME)
< VIBRATOR >
X901
1-781-282-51 VIBRATOR, CERAMIC (4MHz)
*************************************************************
A-1089-525-A PRIMARY BOARD, COMPLETE
************************
< CAPACITOR >
C1201
C1202
C1204
C1206
1-164-156-11
1-164-156-11
1-164-156-11
1-126-916-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
0.1uF
0.1uF
0.1uF
1000uF
20%
25V
25V
25V
6.3V
< CONNECTOR >
CN1200 1-785-329-11 PIN, CONNECTOR (LIGHT ANGLE) 3P
CN1202 1-564-321-00 PIN, CONNECTOR (3.96mm PITCH) 2P
CN1204 1-564-321-00 PIN, CONNECTOR (3.96mm PITCH) 2P
< DIODE >
D1200
6-501-193-01 DIODE 1SS355WTE-17
< JUMPER RESISTOR >
JR1202 1-216-864-11 SHORT CHIP
0
< COIL >
L1201
1-410-666-31 INDUCTOR
18uH
< TRANSISTOR >
Q1200
8-729-120-28 TRANSISTOR 2SC1623-L5L6
< SWITCH >
< RESISTOR >
S900
S901
S902
S903
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
S904
SWITCH, KEYBOARD (DISPLAY)
SWITCH, KEYBOARD (MP3 BOOSTER)
SWITCH, KEYBOARD (EQ BAND)
SWITCH, KEYBOARD
(DIRECTION/TUNER MEMORY)
1-762-875-21 SWITCH, KEYBOARD (REC PAUSE/START)
S910
S911
S912
S913
S914
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
S915
S916
1-762-875-21 SWITCH, KEYBOARD (x)
1-479-229-11 ROTARY ENCODER (TUNING)
SWITCH, KEYBOARD (VIDEO/MD)
SWITCH, KEYBOARD (TV)
SWITCH, KEYBOARD (CD SYNC)
SWITCH, KEYBOARD (nN)
SWITCH, KEYBOARD (X)
R1200
R1201
1-216-829-11 METAL CHIP
1-216-845-11 METAL CHIP
4.7K
100K
5%
5%
1/10W
1/10W
< RELAY >
0 RY1200 1-755-299-11 RELAY
*************************************************************
1-687-132-12 SENSOR BOARD
*************
< CONNECTOR >
CN731
1-785-329-21 PIN, CONNECTOR (LIGHT ANGLE) 3P
73
HCD-LX10000
SENSOR
Ref. No.
SURROUND
Part No.
SW
TRANS
Description
Remarks
Ref. No.
Part No.
Description
IC731
6-600-022-01 IC RPI-576
*************************************************************
0F1241
0F1251
0F1261
0F1271
1-576-537-12
1-576-537-12
1-576-537-12
1-576-537-12
FUSE, GLASS TUBE (DIA.5) (T8AL/125V)
FUSE, GLASS TUBE (DIA.5) (T8AL/125V)
FUSE, GLASS TUBE (DIA.5) (T8AL/125V)
FUSE, GLASS TUBE (DIA.5) (T8AL/125V)
0F1281
FL901
M741
M751
M891
1-533-451-12
1-519-794-21
A-4723-963-A
A-4737-553-A
1-763-372-11
FUSE, GLASS TUBE (DIA.5) (T3.15AL/125V)
VACUUM FLUORESCENT DISPLAYS
MOTOR ASSY, TABLE
MOTOR ASSY, LOADING
FAN, DC
RE701
0T1200
1-477-680-12 ENCODER, ROTARY
1-443-544-11 POWER TRANSFORMER
< IC >
A-1089-321-A SURROUND BOARD, COMPLETE
**************************
*************************************************************
1-687-669-12 SW BOARD
*********
< SWITCH >
S751
1-786-514-11 SWITCH, LEVER (SLIDE) (OPEN)
*************************************************************
A-1089-588-A TRANS BOARD, COMPLETE
**********************
1-533-217-41 HOLDER, FUSE
< CAPACITOR >
C1262
C1263
C1292
1-126-964-11 ELECT
1-126-968-11 ELECT
1-128-576-11 ELECT
10uF
100uF
100uF
20%
20%
20%
50V
50V
63V
< CONNECTOR >
* CN1212 1-564-522-11 PLUG, CONNECTOR 7P
* CN1213 1-564-521-11 PLUG, CONNECTOR 6P
< DIODE >
D1264
D1292
8-719-071-83 DIODE HZU36BTRF
6-500-522-21 DIODE 10EDB40-TB3
< TRANSISTOR >
Q1264
8-729-024-93 TRANSISTOR 2SB1565E
< RESISTOR >
0R1233 1-219-237-11 SOLID
3.3M
20%
1/2W
R1262 1-216-832-11 METAL CHIP
8.2K
5%
1/10W
R1263 1-216-832-11 METAL CHIP
8.2K
5%
1/10W
R1264 1-216-821-11 METAL CHIP
1K
5%
1/10W
0R1292 1-219-124-11 FUSIBLE
0.68
5%
1/4W
*************************************************************
MISCELLANEOUS
**************
5
07
8
65
71
1-693-672-11
1-468-737-61
1-824-048-12
1-828-992-11
1-797-165-11
TUNER (FM/AM) (TM-10U)
POWER SWITCHING
WIRE (FLAT TYPE) (27 CORE)
WIRE (FLAT TYPE) (17 CORE)
DECK, MECHANICAL (CMAT5Z2)
106
0107
109
152
226
1-828-956-11
1-783-820-11
1-828-972-11
1-776-182-11
1-832-404-21
WIRE (FLAT TYPE) (9 CORE)
CORD, POWER
WIRE (FLAT TYPE) (13 CORE)
WIRE (FLAT TYPE) (5 CORE)
CABLE, FLEXIBLE FLAT (16 CORE)
0229
8-820-244-01 OPTICAL PICK-UP KSM-215DCP/C2NP
74
Remarks
HCD-LX10000
US Model
SERVICE MANUAL
Ver. 1.1 2008.01
SUPPLEMENT-1
File this supplement with the service manual.
Subject: Specification change
Specification changes made for serial No. 8891860 and later.
Check the serial No. when servicing and inspecting the set.
This service manual, SUPPLEMENT-1 only contains the change.
9-887-216-81
HCD-LX10000
For schematic diagrams.
Note:
• All capacitors are in µF unless otherwise noted. (p: pF)
50 V or less are not indicated except for electrolytics and
tantalums.
• All resistors are in Ω and 1/4 W or less unless otherwise
specified.
•
%
: indicates tolerance.
•
f
: internal component.
• 2 : nonflammable resistor.
• 5 : fusible resistor.
• C : panel designation.
Note: The components identified by mark 0 or dotted line
with mark 0 are critical for safety.
Replace only with part number specified.
Note on Printed Wiring Boards:
Note:
• X : parts extracted from the component side.
•
: Pattern from the side which enables seeing.
(The other layers' patterns are not indicated.)
Caution:
Parts face side:
(Side A)
Pattern face side:
(Side B)
• Indication of transistor.
C
Q
• A : B+ Line.
• B : B– Line.
• Voltages and waveforms are dc with respect to ground
under no-signal conditions.
no mark: TUNER (FM/AM)
• Voltages are taken with a VOM (Input impedance 10 MΩ).
Voltage variations may be noted due to normal production tolerances.
• Waveforms are taken with a oscilloscope.
Voltage variations may be noted due to normal production tolerances.
• Circled numbers refer to waveforms.
• Signal path.
F
: TUNER (FM/AM)
• <
> : Refer to page of service manual.
These are omitted.
B E
Q
B C
E
These are omitted.
Q
B
C
E
These are omitted.
• <
2
Parts on the parts face side seen from
the parts face are indicated.
Parts on the pattern face side seen from
the pattern face are indicated.
> : Refer to page of service manual.
HCD-LX10000
1. PRINTED WIRING BOARD – PA Board –
: Uses unleaded solder.
C649
R645
F
D624
R630
R628
R627
R626
R632
E
Q628
Q644
JW675
JW674
C683
JW600
JW602
JW691
R691
JW677
EP690
C605
R633
R631
Q630
C654
R625
R624
R674
C604
E
• Semiconductor
Location
R629
Ref. No.
1-864-930-
7
G
P
R681
JW676
D655
R655
R665
E
JW673
1
L
TH630
TH629
JW614
C606
JW613
R653
JW695
JW694
JW603
JW672
NO600
PL600
TM601
R
R650
R600
R652
R603
R651
JWH603
C601
C652
R644
E
L
SURR SPEAKER
JWH602
R601
C651
JW693
C602
JW696
JW627
JW628
JW669
R666
Q647
C693
RY665
Q666
E
JW681
C650
C600
R668
C691
C692
R646
JWH600
R617
R695
R696
JW670
JW671
FRONT SPEAKER
D646
JW606
JW605
JW604
JW616
R
JWH601
JW626
R615
RY646
D665
JW623
JW622
JW621
JW624
C616
C610
C666
C617
JW625
JW629
R673 R623
D620
R692
JW632
JW635
JW631 R611
JW630
R654
R604
R605
R693
R608
R698
R609
JW634
JW633
R612
D654
JW607
JW620
C609
D611 D612
JW668
R647
R648
12
Q629
–
R661
R660
R667
E
JW688
JW608
R602
IC600
C682
C681
C655
R616
JW667
D660
R649
11
TM600
R619
C667
10
JR600
JW617
JW618
JW619
C619
JW647
JW648
JW650
E
R672
JW649
JW645
JW644
JW651
+
8
CN601
R622
C637
C618
1
D670
E Q606 Q604 R671
R621
R607
R670
JR603
R606
R620
R669
E
E
E
Q668
Q618
Q610
C636
JW641
R641
R694
Q640
C635 C608
R634
R697
D658
–
R642
R662
JW639
R639
+
R685
D661
E
JW699
JW700
D656
Q648
Q634
E
JW663
C660
JW665
E
R658
JW662
JW664
C648
E
JW638
E
R640
R610
E
Q682
C658
R676
R677
EP660
PL601
JW643
JW642
JW653
JW652
JW654
R657
R656
C656
JW601
JW660
JW661
D
JW637
R636
JW698
JW659
C
1
Q641
JW658
R683
3
NO601
R678
C6
76
78
C6
JW657
B
JW682
JW683
R663
R637
R643
JW680
JW655
JW656
PL602
JW684
JW679
R682
JW636
13
R635
CN600
JW678
JW640 R638
1
D609
PA BOARD
9
MAIN
BOARD
CN502
<Page 36>
K
R614
N
MIC
BOARD
CN1102
<Page 42>
JW692
MAIN
BOARD
CN501
<Page 36>
8
7
R613
J
A
6
R618
5
C634
4
JW646
3
2
1
TRANS
BOARD
CN1212
<Page 46>
HCD-LX10000
3
3
11
(13)
Location
D609
D611
D612
D620
D624
D646
D654
D655
D656
D658
D660
D661
D665
D670
A-6
E-7
E-7
B-7
E-9
B-10
B-9
B-10
E-4
E-5
E-2
E-2
C-10
B-7
IC600
D-8
Q604
Q606
Q610
Q618
Q628
Q629
Q630
Q634
Q640
Q641
Q644
Q647
Q648
Q666
Q668
Q682
B-7
B-6
B-7
B-7
E-9
D-10
E-9
B-6
B-6
B-5
F-1
F-1
E-2
E-1
B-7
A-6
HCD-LX10000
2. SCHEMATIC DIAGRAM – PA Board –
IC600
STK412-150-K
POWER AMP
<Page 47>
VL(AC)
GND
GND
GND
VH(AC)
VH(AC)
NO600
7P
VL(AC)
TRANS
BOARD
CN1212
Q618
2SC3906K
OVERLOAD DET
R618
0.1
5W
D656
D5SBA60
R656
220k
R657
220k
C656
3300
80V
R668
0.1
5W
R602
680
R612
100
C618
10
100V
R613
3.3k
1W
C602
100
10V
R653
47k
R620
33k
R670
33k
R671
100k
D620
MA111
R621
100k
D670
MA111
C666
0.068
C654
220p
D611
MM3Z18VST1
R619
1k
C652
100
10V
R652
680
Q668
2SC3906K
OVERLOAD DET
R669
1k
C693 C683
0.1
0.1
C605
0.1
R614
3.3k
1W
C676
3300
80V
C616
0.068
R603
47k
C604
220p
D612
MM3Z18VST1
R660
22k
D660
MA111
R661
22k
D661
MA111
R678
100k
R696
100k
R617
100k
R622
10
1/2W
R616
1
R672
10
1/2W
C692
0.068
C682
0.068
C691
0.068
C681
0.068
R691
10
1/2W
R681
10
1/2W
R
SURR SPEAKER
JW691
JW677
C658
3300
50V
R698
100k
R608
100k
Q610
2SC3906K
RY646
JW681
TM600
D609
MA111
JW676
R624
22k
R610
68k
R609
68k
C608
22
50V
R611
33k
C601
0.0022
C651
0.0022
R601
47k
R651
47k
R
R673
56k
R623
68k
R674
22k
R600
1k
Q604,606,610
STANBY SWITCH
R607
2.2k
R655
47k
R654
47k
R694
68k
R693
100k
R606
47k
D655
MA111
C606
0.1
C609
22
100V
C678
3300
50V
C637
4.7
100V
Q640
2SC3661
HEADPHONE
MUTING
R650
1k
Q634
RT1P241C
MUTING
CONTROL SWITCH
Q604
2SC3906K
R604
10k
R692
47k
C600
4.7
50V
R605
10k
C660
100000p
C635
100
25V
R697
2.2k
R635
10k
C634
100
25V
R634
2.2k
C650
4.7
50V
R637
680
2W
R640
1k
Q641
2SC3661
HEADPHONE
MUTING
R682
1k
Q682
2SC3052F
MUTING
CONTROL SWITCH
R638
100k
R642
150
R646
82
1/2W
R639
100k
C636 R636
4.7 680
100V 2W
R685
10k
C648
100
10V
R633
56k
PREGND
POWER GND
POWER GND
R628
22k
R630
100k
CN601
8P
Q630
2SC3052F
TEMPERATURE
DETECT SWITCH
R629
5.6k
TH629
<Page 39>
<Page 39>
HCD-LX10000
4
4
R627
1k
R632
100k
NO601
3P
Q629
2SC3052F
FAN MOTOR
ON SWITCH
TH630
Q628
2SC3052F
TEMPERATURE
DETECT SWITCH
MAIN BOARD
(3/3)
CN502
R626
56k
Q666
2SC3052F
SPEAKER PROTECT
RELAY DRIVE
R666
4.7k
R647
4.7k
R667
10k
Q647
2SC3052F
FRONT SPEAKER
RELAY DRIVE
D624
MA111
R631
100k
D665
MA111
R648
4.7k
R645
10k
EP660
MAIN BOARD
(3/3)
CN501
L
Q644
2SC3052F
FRONT SPEAKER
RELAY DRIVE
R644
2.2k
R643
150
FRONT SPEAKER
RY665
D646
MA111
R665
82
1/2W
R641
1k
R683
4.7k
R625
3.9k
CN600
13P
L
D654
MA111
C655
10
50V
C610
22
100V
Q606
2SA1207
TM601
R695
100k
R615
100
R658
100k
EP690
C617
0.068
C619
10 100V
D658
D5SBA60
C667
0.068
R662 150
R677
220k
R663 150
R676
220k
MIC
BOARD
CN1102
<Page 43>
Q648
C649
2SC3052F
10
OVER LOAD
50V
DETECT SWITCH
R649
22k
HCD-LX10000
3. EXPLODED VIEWS
NOTE:
• -XX, -X mean standardized parts, so they may
have some differences from the original one.
• Items marked “*” are not stocked since they
are seldom required for routine service. Some
delay should be anticipated when ordering
these items.
•
The components identified by mark
0 or dotted line with mark 0 are
critical for safety.
Replace only with part number
specified.
The mechanical parts with no reference
number in the exploded views are not supplied.
Hardware (# mark) list and accessories are
given in the last of this parts list.
•
#1
(1) CASE (TOP), BACK PANEL SECTION
3
#1
2
not supplied
not supplied
#1
#1
#1
#1
4
CD mechanism
deck section
1
#1
M891
#1
#1
#1
10
6
#2
#1
#1
not
supplied
9
5
not supplied
#1
not supplied
#2
8
#2
7
#1
not supplied
9
#1
3
#1
not supplied
#1
not supplied
4
Ref. No.
1
2
3
4
5
6
07
Part No.
Description
X-2109-678-1
2-342-117-21
3-363-099-32
3-363-099-02
1-693-672-11
LOADING PANEL ASSY
CASE (TOP)
SCREW (CASE 3 TP2)
SCREW (CASE 3 TP2)
TUNER (FM/AM) (TM-10U)
A-1089-525-A PRIMARY BOARD, COMPLETE
1-468-737-71 POWER SWITCHING
Remark
Ref. No.
Part No.
Description
8
9
10
M891
#1
1-824-048-12
3-077-331-21
3-378-109-12
1-763-372-11
7-685-647-79
WIRE (FLAT TYPE) (27 CORE)
+BV3 (3-CR)
CUSHION, SARANET
FAN, DC
SCREW +BVTP 3X10 TYPE2 IT-3
#2
7-685-646-79 SCREW +BVTP 3X8 TYPE2 IT-3
Remark
5
HCD-LX10000
(2) FRONT PANEL SECTION
58
58
58
64
not supplied
58
FL901
68
65
66
58
69
58
67
not supplied
58
69
not supplied
not supplied
58
70
58
60
62
59
61
not supplied
56
57
58
58
56
58
71
55
58
54
52 53
51
Ref. No.
6
Part No.
Description
51
52
53
54
55
X-2025-429-1
2-342-128-01
2-342-108-01
2-342-134-01
2-342-111-01
FRONT PANEL ASSY
ESCUTHEON (LID)
LID (TC)
SPRING (LID)
HOLDER (TC-R)
56
57
58
59
60
4-959-229-11
2-342-110-01
3-087-053-01
4-224-578-21
2-342-104-01
DETENT, CASSETTE
HOLDER (TC-L)
+BVTP2.6 (3CR)
KNOB (MIC)
KNOB (AMS)
61
4-252-575-01 KNOB VOL
Remark
Ref. No.
Part No.
Description
62
64
65
66
X-2025-430-1
3-077-331-21
1-828-992-11
A-1089-463-A
KNOB JOG ASSY
+BV3 (3-CR)
WIRE (FLAT TYPE) (17 CORE)
PANEL BOARD, COMPLETE
67
68
69
70
71
2-342-136-01
2-342-135-01
4-224-104-11
A-1089-466-A
1-797-165-11
SPRING (R)
SPRING (L)
DAMPER
MIC BOARD, COMPLETE
DECK, MECHANICAL (CMAT5Z2)
FL901
1-519-794-21 VACUUM FLUORESCENT DISPLAYS
Remark
HCD-LX10000
(3) CHASSIS SECTION
not supplied
111
103
not supplied
#1
107
108
#1
111
111
D658
not supplied
F1281
D656
111
F1271
F1261
F1251
105
106
F1241
101
#1
102
#1
101
T1200
#1
#1
109
#1
110
not supplied
Ref. No.
Part No.
Description
101
102
103
105
106
4-900-386-01
A-1089-586-A
A-1089-588-A
3-905-609-31
1-828-956-11
0 107
* 108
109
110
111
1-783-820-11
3-703-244-00
1-828-972-11
A-1189-961-A
3-077-331-21
Remark
Ref. No.
Part No.
Description
Remark
SCREW
PA BOARD, COMPLETE
TRANS BOARD, COMPLETE
SCREW (TRANSISTOR)
WIRE (FLAT TYPE) (9 CORE)
0 F1241
0 F1251
0 F1261
0 F1271
0 F1281
1-576-537-12
1-576-537-12
1-576-537-12
1-576-537-12
1-533-451-12
FUSE, GLASS TUBE (DIA.5) (T8AL/125V)
FUSE, GLASS TUBE (DIA.5) (T8AL/125V)
FUSE, GLASS TUBE (DIA.5) (T8AL/125V)
FUSE, GLASS TUBE (DIA.5) (T8AL/125V)
FUSE, GLASS TUBE (DIA.5) (T3.15AL/125V)
CORD, POWER
BUSHING (2104), CORD
WIRE (FLAT TYPE) (13 CORE)
MAIN BOARD, COMPLETE
+BV3 (3-CR)
* D656
* D658
0 T1200
#1
8-719-500-62
8-719-500-62
1-445-342-11
7-685-647-79
DIODE D5SBA60
DIODE D5SBA60
POWER TRANSFORMER
SCREW +BVTP 3X10 TYPE2 IT-3
7
HCD-LX10000
PA
4. ELECTRICAL PARTS LIST
NOTE:
• Due to standardization, replacements in the
parts list may be different from the parts
specified in the diagrams or the components
used on the set.
• -XX and -X mean standardized parts, so they
may have some difference from the original
one.
• RESISTORS
All resistors are in ohms.
METAL: Metal-film resistor.
METAL OXIDE: Metal oxide-film resistor.
F: nonflammable
Ref. No.
Part No.
•
•
•
•
The components identified by mark
0 or dotted line with mark 0 are
critical for safety.
Replace only with part number
specified.
Items marked “*” are not stocked since they
are seldom required for routine service.
Some delay should be anticipated when
ordering these items.
SEMICONDUCTORS
In each case, u : µ, for example:
uA.. : µA.. uPA.. : µPA..
uPB.. : µPB.. uPC.. : µPC.. uPD.. : µPD..
CAPACITORS
uF : µF
COILS
uH : µH
Description
Remark
Ref. No.
CN601
A-1089-586-A PA BOARD, COMPLETE
*******************
Part No.
When indicating parts by reference
number, please include the board.
Description
Remark
1-784-031-41 CONNECTOR, BOARD TO BOARD 8P
< DIODE >
< CAPACITOR >
C600
C601
C602
C604
C605
1-126-963-11
1-162-966-11
1-104-658-11
1-162-960-11
1-131-992-11
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
4.7uF
0.0022uF
100uF
220PF
0.1uF
20%
10%
20%
10%
50V
50V
10V
50V
35V
C606
C608
C609
C610
C616
1-131-992-11
1-126-965-11
1-128-560-11
1-128-560-11
1-136-495-11
CERAMIC CHIP
ELECT
ELECT
ELECT
FILM
0.1uF
22uF
22uF
22uF
0.068uF
20%
20%
20%
5%
35V
50V
100V
100V
50V
C617
C618
C619
C634
C635
1-136-495-11
1-128-582-11
1-128-582-11
1-104-665-11
1-104-665-11
FILM
ELECT
ELECT
ELECT
ELECT
0.068uF
10uF
10uF
100uF
100uF
5%
20%
20%
20%
20%
50V
100V
100V
25V
25V
C636
C637
C648
C649
C650
1-107-721-11
1-107-721-11
1-104-658-11
1-126-964-11
1-126-963-11
ELECT
ELECT
ELECT
ELECT
ELECT
4.7uF
4.7uF
100uF
10uF
4.7uF
20%
20%
20%
20%
20%
100V
100V
10V
50V
50V
C651
C652
C654
C655
C656
1-162-966-11
1-104-658-11
1-162-960-11
1-126-964-11
1-127-814-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
ELECT(BLOCK)
0.0022uF
100uF
220PF
10uF
3300uF
10%
20%
10%
20%
20%
50V
10V
50V
50V
80V
C658
C660
C666
C667
C676
1-126-974-11
1-131-992-11
1-136-495-11
1-136-495-11
1-127-814-11
ELECT
CERAMIC CHIP
FILM
FILM
ELECT(BLOCK)
3300uF
0.1uF
0.068uF
0.068uF
3300uF
20%
50V
35V
50V
50V
80V
C678
C681
C682
C683
C691
1-126-974-11
1-110-563-11
1-110-563-11
1-131-992-11
1-110-563-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
3300uF
0.068uF
0.068uF
0.1uF
0.068uF
20%
10%
10%
C692
C693
1-110-563-11 CERAMIC CHIP
1-131-992-11 CERAMIC CHIP
0.068uF
0.1uF
10%
D609
D611
D612
D620
D624
8-719-404-50
8-719-056-93
8-719-056-93
8-719-404-50
8-719-404-50
DIODE
DIODE
DIODE
DIODE
DIODE
MA111-TX
UDZ-TE-17-18B
UDZ-TE-17-18B
MA111-TX
MA111-TX
D646
D654
D655
D660
D661
8-719-404-50
8-719-404-50
8-719-404-50
8-719-404-50
8-719-404-50
DIODE
DIODE
DIODE
DIODE
DIODE
MA111-TX
MA111-TX
MA111-TX
MA111-TX
MA111-TX
D665
D670
8-719-404-50 DIODE MA111-TX
8-719-404-50 DIODE MA111-TX
< IC >
IC600
6-712-133-01 IC STK412-150-K
< JUMPER RESISTOR >
JR600
JR603
1-216-296-11 SHORT CHIP
1-216-296-11 SHORT CHIP
0
0
< TRANSISTOR >
5%
5%
20%
10%
50V
16V
16V
35V
16V
16V
35V
Q604
Q606
Q610
Q618
Q628
8-729-924-99
8-729-821-00
8-729-924-99
8-729-924-99
8-729-120-28
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC3722K-E
2SA1207
2SC3722K-E
2SC3722K-E
2SC1623-L5L6
Q629
Q630
Q634
Q640
Q641
8-729-120-28
8-729-120-28
8-729-027-31
8-729-802-80
8-729-802-80
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC1623-L5L6
2SC1623-L5L6
DTA124EKA-T146
2SC3661
2SC3661
Q644
Q647
Q648
Q666
Q668
8-729-120-28
8-729-120-28
8-729-120-28
8-729-120-28
8-729-924-99
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC1623-L5L6
2SC1623-L5L6
2SC1623-L5L6
2SC1623-L5L6
2SC3722K-E
Q682
8-729-120-28 TRANSISTOR 2SC1623-L5L6
< RESISTOR >
< CONNECTOR >
CN600
8
1-764-865-41 CONNECTOR, BOARD TO BOARD 13P
R600
1-216-821-11 METAL CHIP
1K
5%
1/10W
HCD-LX10000
PA
Ref. No.
Part No.
Description
Remark
Ref. No.
Part No.
Description
R601
R602
R603
R604
R605
1-216-841-11
1-216-819-11
1-216-841-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
680
47K
10K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R660
R661
R662
R663
0 R665
1-216-837-11
1-216-837-11
1-216-811-11
1-216-811-11
1-260-086-31
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
CARBON
Remark
R606
R607
R608
R609
R610
1-216-841-11
1-216-825-11
1-216-845-11
1-216-843-11
1-216-843-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
2.2K
100K
68K
68K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R666
R667
0 R668
R669
R670
1-216-829-11
1-216-833-11
1-234-798-11
1-216-821-11
1-216-839-11
METAL CHIP
4.7K
5%
1/10W
METAL CHIP
10K
5%
1/10W
ENCAPSULATED COMPONENT 0.1X2 5W
METAL CHIP
1K
5%
1/10W
METAL CHIP
33K
5%
1/10W
R611
0 R612
0 R613
0 R614
0 R615
1-216-839-11
1-245-605-51
1-215-872-11
1-215-872-11
1-245-605-51
METAL CHIP
FUSIBLE
METAL OXIDE
METAL OXIDE
FUSIBLE
33K
100
3.3K
3.3K
100
5%
5%
5%
5%
5%
1/10W
1/4W
1W
1W
1/4W
F
F
F
F
R671
R672
R673
R674
R676
1-216-845-11
1-245-711-31
1-216-842-11
1-216-837-11
1-216-849-11
METAL CHIP
CARBON
METAL CHIP
METAL CHIP
METAL CHIP
100K
10
56K
22K
220K
5%
5%
5%
5%
5%
1/10W
1/2W F
1/10W
1/10W
1/10W
0 R616
R617
0 R618
R619
R620
1-217-637-00
1-216-845-11
1-234-798-11
1-216-821-11
1-216-839-11
FUSIBLE
1
5%
1/4W F
METAL CHIP
100K
5%
1/10W
ENCAPSULATED COMPONENT 0.1X2 5W
METAL CHIP
1K
5%
1/10W
METAL CHIP
33K
5%
1/10W
R677
R678
R681
R682
R683
1-216-849-11
1-216-845-11
1-245-711-31
1-216-821-11
1-216-829-11
METAL CHIP
METAL CHIP
CARBON
METAL CHIP
METAL CHIP
220K
100K
10
1K
4.7K
5%
5%
5%
5%
5%
1/10W
1/10W
1/2W F
1/10W
1/10W
R621
R622
R623
R624
R625
1-216-845-11
1-245-711-31
1-216-843-11
1-216-837-11
1-216-828-11
METAL CHIP
CARBON
METAL CHIP
METAL CHIP
METAL CHIP
100K
10
68K
22K
3.9K
5%
5%
5%
5%
5%
1/10W
1/2W F
1/10W
1/10W
1/10W
R685
R691
R692
R693
R694
1-216-833-11
1-245-711-31
1-216-841-11
1-216-845-11
1-216-843-11
METAL CHIP
CARBON
METAL CHIP
METAL CHIP
METAL CHIP
10K
10
47K
100K
68K
5%
5%
5%
5%
5%
1/10W
1/2W F
1/10W
1/10W
1/10W
R626
R627
R628
R629
R630
1-216-842-11
1-216-821-11
1-216-837-11
1-216-830-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
56K
1K
22K
5.6K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R695
R696
R697
R698
1-216-845-11
1-216-845-11
1-216-825-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
100K
2.2K
100K
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
R631
R632
R633
R634
R635
1-216-845-11
1-216-845-11
1-216-842-11
1-216-825-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
100K
56K
2.2K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
0 R636
0 R637
R638
R639
R640
1-215-891-11
1-215-891-11
1-216-845-11
1-216-845-11
1-216-821-11
METAL OXIDE
METAL OXIDE
METAL CHIP
METAL CHIP
METAL CHIP
680
680
100K
100K
1K
5%
5%
5%
5%
5%
2W
F
2W
F
1/10W
1/10W
1/10W
R641
R642
R643
R644
R645
1-216-821-11
1-216-811-11
1-216-811-11
1-216-825-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
150
150
2.2K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
0 R646
R647
R648
R649
R650
1-260-086-31
1-216-829-11
1-216-829-11
1-216-837-11
1-216-821-11
CARBON
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
82
4.7K
4.7K
22K
1K
5%
5%
5%
5%
5%
1/2W F
1/10W
1/10W
1/10W
1/10W
R651
R652
R653
R654
R655
1-216-841-11
1-216-819-11
1-216-841-11
1-216-841-11
1-216-841-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
680
47K
47K
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R656
R657
R658
1-216-849-11 METAL CHIP
1-216-849-11 METAL CHIP
1-216-845-11 METAL CHIP
220K
220K
100K
5%
5%
5%
1/10W
1/10W
1/10W
22K
22K
150
150
82
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/2W F
< RELAY >
RY646
RY665
1-755-500-11 RELAY
1-755-500-11 RELAY
< THERMISTOR >
TH629
TH630
1-807-796-11 THERMISTOR
1-807-796-11 THERMISTOR
< TERMINAL BOARD >
TM600 1-820-067-11 TERMINAL BOARD (FRONT SPEAKER)
TM601 1-820-067-11 TERMINAL BOARD (SURR SPEAKER)
*************************************************************
9
HCD-LX10000
Ref. No.
Part No.
Description
Remark
MISCELLANEOUS
***************
5
07
8
65
71
1-693-672-11
1-468-737-71
1-824-048-12
1-828-992-11
1-797-165-11
TUNER (FM/AM) (TM-10U)
SWITCHING, POWER
WIRE (FLAT TYPE) (27 CORE)
WIRE (FLAT TYPE) (17 CORE)
DECK, MECHANICAL (CMAT5Z2)
106
0 107
109
* D656
* D658
1-828-956-11
1-783-820-11
1-828-972-11
8-719-500-62
8-719-500-62
WIRE (FLAT TYPE) (9 CORE)
CORD, POWER
WIRE (FLAT TYPE) (13 CORE)
DIODE D5SBA60
DIODE D5SBA60
0 F1241
0 F1251
0 F1261
0 F1271
0 F1281
1-576-537-12
1-576-537-12
1-576-537-12
1-576-537-12
1-533-451-12
FUSE, GLASS TUBE (DIA. 5) (T8AL/125V)
FUSE, GLASS TUBE (DIA. 5) (T8AL/125V)
FUSE, GLASS TUBE (DIA. 5) (T8AL/125V)
FUSE, GLASS TUBE (DIA. 5) (T8AL/125V)
FUSE, GLASS TUBE (DIA. 5) (T3.15AL/125V)
M891
0 T1200
1-763-372-11 FAN, DC
1-445-342-11 TRANSFORMER, POWER
10
HCD-LX10000
MEMO
11
HCD-LX10000
REVISION HISTORY
Clicking the version allows you to jump to the revised page.
Also, clicking the version at the top of the revised page allows you to jump to the next revised page.
2
Ver.
Date
Description of Revision
1.0
2006.04
New
1.1
2008.01
Specification change. (Supplement-1)
(ENG-07013)