Download Nokia 5530 Xpress Music Service Manual Level 1&2

Nokia 5530 XpressMusic RM-504
Service Manual Level 1&2
SERVICE MANUAL
Level 1&2
RM-504
Transceiver characteristics
Band:
GSM/EDGE 850/900/1800/1900
Display:
Touch screen (Full touch UI) nHD (640*360px),
2.9”/active area, 36.18mm x 64.32 mm colour display,
up to 16M colours
Automatic orientation sensor for display rotation
Camera:
3.2 Mpix, 4 x digital zoom
Operating System:
Series 60 release Taco 5.0
Connections:
•
•
•
•
•
Bluetooth 2.0 (A2DP/AVRCP)
2.0 Charger connector
USB 2.0 high speed through micro-USB interface
3.5 mm Nokia AV connector
Micro SD card (hot swap)
Transceiver with BL-4U battery pack
1
Talk time
Standby
GSM:
Up to 4.9 hours
GSM:
Talk times are
Up to 351 hours dependent on
network
parameters and
phone settings
Confidential • Copyright © 2010 Nokia • All rights reserved
Note
Version 7.0
Nokia 5530 XpressMusic RM-504
Service Manual Level 1&2
Table of contents
1.
1T
Change history .......................................................................................................................................................................... 3
1T
1T
2.
1T
Copyright .................................................................................................................................................................................... 4
1T
1T
3.
1T
1T
3.1
1T
3.2
1T
4.
2
1T
1T
SW-update ............................................................................................................................................................................... 11
1T
12.
1T
1T
9.
1T
1T
Service devices ........................................................................................................................................................................ 10
1T
11.
1T
1T
8.
1T
1T
Exploded view .......................................................................................................................................................................... 9
1T
10.
Cautions ............................................................................................................................................................................. 5
1T
7.
1T
1T
Battery information ................................................................................................................................................................ 8
1T
1T
1T
1T
1T
6.
1T
1T
Care and maintenance ........................................................................................................................................................... 7
1T
1T
Warnings ........................................................................................................................................................................... 5
1T
1T
5.
1T
1T
ESD protection .......................................................................................................................................................................... 6
1T
1T
1T
Warnings and cautions .......................................................................................................................................................... 5
1T
1T
1T
1T
1T
Disassembly instructions ................................................................................................................................................ 12
1T
1T
1T
1T
1T
1T
1T
Assembly hints ................................................................................................................................................................... 18
1T
Solder components .......................................................................................................................................................... 20
1T
Confidential • Copyright © 2010 Nokia • All rights reserved
Version 7.0
Nokia 5530 XpressMusic RM-504
Service Manual Level 1&2
1. CHANGE HISTORY
0B
Status
Version No.
Date
Approved
Approved
1.0
2.0
28.5.2009
17.6.2009
Approved
Approved
Approved
3.0
4.0
5.0
31.8.2009
17.12.2009
17.2.2010
Approved
Approved
6.0
7.0
25.2.2010
24.3.2010
Comments
Assembly screw order
updated, Exploded view
updated
Exploded view updated
Exploded view updated
Exploded view and
disassembly sequence
updated
Exploded view updated
S2500 component position
in solder components
corrected
The purpose of this document is to help NOKIA service levels 1 and 2 workshop technicians to
carry out service to NOKIA products. This Service Manual is to be used only by authorized NOKIA
service suppliers, and the content of it is confidential. Please note that NOKIA provides also other
guidance documents (e.g. Service Bulletins) for service suppliers, follow these regularly and
comply with the given instructions.
While every endeavor has been made to ensure the accuracy of this document, some errors may
exist. If you find any errors or if you have further suggestions, please notify NOKIA using the
address below:
Nokia Care Academy
[email protected]
1TU
Please keep in mind also that this documentation is continuously being updated and modified,
so watch always out for the newest version.
3
Confidential • Copyright © 2010 Nokia • All rights reserved
Version 7.0
Nokia 5530 XpressMusic RM-504
Service Manual Level 1&2
2. COPYRIGHT
1B
Copyright © 2010 Nokia. All rights reserved.
Reproduction, transfer, distribution or storage of part or all of the contents in this document in
any form without the prior written permission of Nokia is prohibited.
Nokia, Nokia Connecting People, and Nokia X and Y are trademarks or registered trademarks of
Nokia Corporation. Other product and company names mentioned herein may be trademarks or
tradenames of their respective owners.
Nokia operates a policy of continuous development. Nokia reserves the right to make changes
and improvements to any of the products described in this document without prior notice.
Under no circumstances shall Nokia be responsible for any loss of data or income or any special,
incidental, consequential or indirect damages howsoever caused.
The contents of this document are provided “as is”. Except as required by applicable law, no
warranties of any kind, either express or implied, including, but not limited to, the implied
warranties of merchantability and fitness for a particular purpose, are made in relation to the
accuracy, reliability or contents of this document. Nokia reserves the right to revise this
document or withdraw it at any time without prior notice.
The availability of particular products may vary by region.
IMPORTANT
This document is intended for use by qualified service personnel only.
4
Confidential • Copyright © 2010 Nokia • All rights reserved
Version 7.0
Nokia 5530 XpressMusic RM-504
Service Manual Level 1&2
3. WARNINGS AND CAUTIONS
2B
Please refer to the phone’s user guide for instructions relating to operation, care and
maintenance including important safety information. Note also the following:
3.1
12B
Warnings
1. CARE MUST BE TAKEN ON INSTALLATION IN VEHICLES FITTED WITH ELECTRONIC ENGINE
MANAGEMENT SYSTEMS AND ANTI–SKID BRAKING SYSTEMS. UNDER CERTAIN FAULT CONDITIONS,
EMITTED RF ENERGY CAN AFFECT THEIR OPERATION. IF NECESSARY, CONSULT THE VEHICLE
DEALER/MANUFACTURER TO DETERMINE THE IMMUNITY OF VEHICLE ELECTRONIC SYSTEMS TO RF
ENERGY.
2. THE HANDPORTABLE TELEPHONE MUST NOT BE OPERATED IN AREAS LIKELY TO CONTAIN
POTENTIALLY EXPLOSIVE ATMOSPHERES, EG PETROL STATIONS (SERVICE STATIONS), BLASTING
AREAS ETC.
3. OPERATION OF ANY RADIO TRANSMITTING EQUIPMENT, INCLUDING CELLULAR TELEPHONES, MAY
INTERFERE WITH THE FUNCTIONALITY OF INADEQUATELY PROTECTED MEDICAL DEVICES. CONSULT
A PHYSICIAN OR THE MANUFACTURER OF THE MEDICAL DEVICE IF YOU HAVE ANY QUESTIONS.
OTHER ELECTRONIC EQUIPMENT MAY ALSO BE SUBJECT TO INTERFERENCE.
3.2
13B
Cautions
1. Servicing and alignment must be undertaken by qualified personnel only.
2.
Ensure all work is carried out at an anti–static workstation and that an anti–static wrist
strap is worn.
3. Use only approved components as specified in the parts list.
4. Ensure all components, modules screws and insulators are correctly re–fitted after servicing
and alignment.
5. Ensure all cables and wires are repositioned correctly
5
Confidential • Copyright © 2010 Nokia • All rights reserved
Version 7.0
Nokia 5530 XpressMusic RM-504
Service Manual Level 1&2
4. ESD PROTECTION
3B
Nokia requires that service points have sufficient ESD protection (against static
electricity) when servicing the phone.
Any product of which the covers are removed must be handled with ESD
protection. The SIM card can be replaced without ESD protection if the product
is otherwise ready for use.
To replace the covers ESD protection must be applied.
All electronic parts of the product are susceptible to ESD. Resistors, too, can be
damaged by static electricity discharge.
All ESD sensitive parts must be packed in metallized protective bags during
shipping and handling outside any ESD Protected Area (EPA).
Every repair action involving opening the product or handling the product
components must be done under ESD protection.
ESD protected spare part packages MUST NOT be opened/closed out of an ESD
Protected Area.
For more information and local requirements about ESD protection and ESD
Protected Area, contact your local Nokia After Market Services representative.
6
Confidential • Copyright © 2010 Nokia • All rights reserved
Version 7.0
Nokia 5530 XpressMusic RM-504
Service Manual Level 1&2
5. CARE AND MAINTENANCE
4B
This product is of superior design and craftsmanship and should be treated with care. The
suggestions below will help you to fulfil any warranty obligations and to enjoy this product for
many years.
•
Keep the phone and all its parts and accessories out of the reach of small children.
•
Keep the phone dry. Precipitation, humidity and all types of liquids or moisture can
contain minerals that will corrode electronic circuits.
•
Do not use or store the phone in dusty, dirty areas. Its moving parts can be
damaged.
•
Do not store the phone in hot areas. High temperatures can shorten the life of
electronic devices, damage batteries, and warp or melt certain plastics.
•
Do not store the phone in cold areas. When it warms up (to its normal temperature),
moisture can form inside, which may damage electronic circuit boards.
•
Do not drop, knock or shake the phone. Rough handling can break internal circuit
boards.
•
Do not use harsh chemicals, cleaning solvents, or strong detergents to clean the
phone.
•
Do not paint the phone. Paint can clog the moving parts and prevent proper
operation.
•
Use only the supplied or an approved replacement antenna. Unauthorised antennas,
modifications or attachments could damage the phone and may violate regulations
governing radio devices.
All of the above suggestions apply equally to the product, battery, charger or any accessory.
7
Confidential • Copyright © 2010 Nokia • All rights reserved
Version 7.0
Nokia 5530 XpressMusic RM-504
Service Manual Level 1&2
6. BATTERY INFORMATION
5B
Note: A new battery’s full performance is achieved only after two or three complete charge and
discharge cycles! The battery can be charged and discharged hundreds of times but it will
eventually wear out.
When the operating time (talk-time and standby time) is noticeably shorter than normal, it is
time to buy a new battery. Use only batteries approved by the phone manufacturer and
recharge the battery only with the chargers approved by the manufacturer.
Unplug the charger when not in use. Do not leave the battery connected to a charger for longer
than a week, since overcharging may shorten its lifetime.
If left unused a fully charged battery will discharge itself over time Temperature extremes can
affect the ability of your battery to charge.
For good operation times with Ni-Cd/NiMh batteries, discharge the battery from time to time by
leaving the product switched on until it turns itself off (or by using the battery discharge facility
of any approved accessory available for the product).
Do not attempt to discharge the battery by any other means Use the battery only for its
intended purpose.
Never use any charger or battery which is damaged.
Do not short-circuit the battery. Accidental short-circuiting can occur when a metallic object
(coin, clip or pen) causes direct connection of the + and - terminals of the battery (metal strips
on the battery) for example when you carry a spare battery in your pocket or purse.
Shortcircuiting the terminals may damage the battery or the connecting object.
Leaving the battery in hot or cold places, such as in a closed car in summer or winter conditions,
will reduce the capacity and lifetime of the battery. Always try to keep the battery between 15°C
and 25°C (59°F and 77°F).
A phone with a hot or cold battery may temporarily not work, even when the battery is fully
charged. Batteries’ performance is particularly limited in temperatures well below freezing.
Do not dispose batteries in a fire! Dispose of batteries according to local regulations (e.g.
recycling).
Do not dispose as household waste.
8
Confidential • Copyright © 2010 Nokia • All rights reserved
Version 7.0
Nokia 5530 XpressMusic RM-504
Service Manual Level 1&2
7. EXPLODED VIEW
6B
A-COVER ASSY
I0001
TOUCH WINDOW ASSEMBLY
I0003
TOUCH WINDOW
SUPPORT PLATE ASSEMBLY
I0002
LCD nHD AM TFT
I0004
SCREW 1.4X2.5
I0006
SCREW 1.6X6.5
I0005
UI FLEX ASSY
I0009
A1=UI DECK ASSEMBLY
(I0007-I0008, I0010-I0013)
UPPER FLEX
AND BOOT ASSY
I0008
EARPIECE ASSY
I0007
UI-DECK
I0010
CLAPTON EMC MICROPHONE
I0011
SEALIN GASKET FRONT
I0013
IHF SPEAKER
I0012
FM SHIELDING LID
I0017
BW SHIELD LID
I0016
LNA SHIELD LID
I0019
A2=LIGHT SWAP PACKAGE (I0014-I0020)
RF 2 SHIELDING LID
I0014
BB SHIELD LID
I0015
TOUCH SHIELD TAPE
I0033
TYPE LABEL
I0020
LIGHT SWAP PWB
I0018
CAMERA MOD 3M
I0021
USB DOOR
I0028
CONN CHR DIA 2.0mm
I0025
A3=C-COVER ASSY (I0022-I0027)
IHF SPEAKER
I0022
IHF GASKET
I0023
CARD DOOR
I0024
SLOT GASKET
I0031
VOLUME KEY
I0034
STYLUS
I0027
C-COVER
I0026
BATTERY COVER GASKET
I0032
ANTENNA ASSY
I0029
BATTERY COVER
I0030
Ver. 6.0
9
Only available as
assembly
Confidential • Copyright © 2010 Nokia • All rights reserved
These parts can not be
reused after removal
Version 7.0
Nokia 5530 XpressMusic RM-504
Service Manual Level 1&2
8. SERVICE DEVICES
7B
FLS-5 Flash Device
CA-101 Service Cable
V2.0
BL-4U Battery
10
V3.0
SS-210 v2.0/3.0 Camera removal
tool
AC-3 Travel Charger
NMP standard toolkit (v2)
For more information, refer to the
Service Bulletin (SB-011) on NOKIA
Online. Supplier or manufacturer
contacts for tool re-order can be
found in “Recommended service
equipment” document on NOKIA
Online.
Confidential • Copyright © 2010 Nokia • All rights reserved
Version 7.0
Nokia 5530 XpressMusic RM-504
Service Manual Level 1&2
9. SW-UPDATE
8B
Flash concept (Point of Sales)
To use the FLS-5 Flash Dongle, follow the user guide inside the sales package.
Please check always for the latest version of flash software, wich is available on Nokia Online.
11
Confidential • Copyright © 2010 Nokia • All rights reserved
Version 7.0
Nokia 5530 XpressMusic RM-504
Service Manual Level 1&2
10. DISASSEMBLY INSTRUCTIONS
9B
1) Nokia 5530 XpressMusic disassembly.
2) You must use the Nokia Standard Toolkit version
2. You will also need the SS-210 v2.0/3.0 camera
removal tool, AV plug and the 2 mm charger plug.
3) To remove the BATTERY COVER, use the finger
groove to release the cover. If there is a battery
inserted, remove it also.
4) Protect the camera lens with protective film.
4) Start releasing the A-COVER from the card door
area. Insert the SRT-6 between the covers and slide
it around the phone. Be careful not to damage the
A-COVER edges!
6) Remove the A-COVER. Make sure the speaker
mesh stays in its place underneath the cover.
12
Confidential • Copyright © 2010 Nokia • All rights reserved
Version 7.0
Nokia 5530 XpressMusic RM-504
Service Manual Level 1&2
7) Protect the TOUCH WINDOW ASSEMBLY with
protective film.
8) Use the dental tool to carefully release the clips
holding the TOUCH WINDOW ASSEMBLY.
9) Turn the TOUCH WINDOW ASSEMBLY next to the
phone.
10) Protect the inner side of the TOUCH WINDOW
ASSEMBLY and the LCD with protective film.
11) Turn the LCD over to gain access to the LCD
connector. Then use the SS-93 to unlock the locking
mechanism of the LCD connector. While opening
the connector, be careful to not to damage the
connector!
12) Carefully disconnect the LCD connector and
remove the LCD.
13
Confidential • Copyright © 2010 Nokia • All rights reserved
Version 7.0
Nokia 5530 XpressMusic RM-504
Service Manual Level 1&2
13) Unscrew the two TORX+ size 4 screws in the
order shown. Do not use them again.
14) Then unscrew these four TORX+ size 6 screws in
the order shown. Do not use them again.
15) Use the SS-93 to carefully lift up the UI DECK to
gain access to the upper flex connector.
16) Disconnect the UPPER FLEX from the engine
board with the SS-93. While opening the connector,
be careful to not to damage the connector - or
components nearby!
17) Lift the UI DECK and place it on top of the TOUCH
WINDOW ASSEMBLY.
18) Use the SS-93 to disconnect the UI FLEX ASSY
from the engine board. While opening the
connector, be careful to not to damage it!
14
Confidential • Copyright © 2010 Nokia • All rights reserved
Version 7.0
Nokia 5530 XpressMusic RM-504
Service Manual Level 1&2
19) Turn the UI DECK over.
20) Open the TOUCH WINDOW ASSEMBLY connector
with the SS-93. Be careful with the components
around the connector! The TOUCH WINDOW
ASSEMBLY can now be removed. NOTE: If the TOUCH
WINDOW ASSEMBLY is not faulty or damaged, it can
used again. If either the TOUCH WINDOW ASSEMBLY
or the TOUCH WINDOW SUPPORT PLATE ASSEMBLY is
faulty or damaged, both parts must be changed.
21) Use the SS-93 to lift up the LIGHT SWAP PWB and
remove it.
22) Push out the audio connector with the AV plug.
Be careful not to damage the audio connector while
releasing it - or the flex soldering! Avoid pulling the
flex while detaching the AV connector!
23) The UI Deck can be taken away.
24) Use the charger plug to detach the DC jack from
C-COVER ASSY. Remove the DC jack with the
tweezers.
15
Confidential • Copyright © 2010 Nokia • All rights reserved
Version 7.0
Nokia 5530 XpressMusic RM-504
Service Manual Level 1&2
25) Use the sharp end of the SS-93 to release the
clip holding the ANTENNA ASSEMBLY.
26) Turn the C-COVER over and detach the ANTENNA
ASSEMBLY.
27) Use the dental tool to release the IHF SPEAKER
and remove it with the tweezers. Be careful not to
damage the IHF gasket! The speaker and the
speaker adhesive cannot be reused.
28) Push the end of the USB DOOR with the dental
tool as shown.
29) Turn the C-cover over. Push the clip with the
dental tool and keep the clip pressed while pulling
the door out.
30) Use the dental tool to release the IHF SPEAKER.
Be careful not to damage the IHF gasket! The
speaker and the speaker adhesive cannot be reused.
Also remove the MICROPHONE with the dental tool.
16
Confidential • Copyright © 2010 Nokia • All rights reserved
Version 7.0
Nokia 5530 XpressMusic RM-504
Service Manual Level 1&2
31) Use the tweezers to lever out the EARPIECE
ASSEMBLY.
32) Bend the UPPER FLEX AND BOOT ASSY as shown
and then use the SS-93 to detach the flex from the
deck.
Be careful not to damage the flex!
33) Use the dental tool to carefully lever out the RF
2, BB, BW and the FM SHIELD LIDS. These lids cannot
be used again.
34) Remove also the LNA SHIELD LID from the
bottom side of the engine board.
35) Place the camera removal tool SS-210 on top of
the camera. Press down carefully the black plastic
parts of the SS-210. Then press down the metal
sheets. Press the metal plates from the sides to
tighten them to camera. Lift up the SS-210 - and
remove the CAMERA.
36) Nokia 5530 XpressMusic disassembly is now
complete.
17
-END OF DISASSEMBLY-
Confidential • Copyright © 2010 Nokia • All rights reserved
Version 7.0
Nokia 5530 XpressMusic RM-504
Service Manual Level 1&2
11. ASSEMBLY HINTS
10B
1) Connect the TOUCH WINDOW ASSEMBLY to the
engine board.
2) Then connect the UI DECK ASSEMBLY to the
engine board.
3) Place the UI DECK over the engine board and
connect the UPPER FLEX.
4) Tighten the four TORX + size 6 screws to the
torque of 18 Ncm in the order shown.
5) Tighten the two TORX + size 4 screws to the
torque of 15 Ncm in the order shown.
18
Confidential • Copyright © 2010 Nokia • All rights reserved
Version 7.0
Nokia 5530 XpressMusic RM-504
Service Manual Level 1&2
TOUCH WINDOW SUPPORT PLATE ASSEMBLY and
TOUCH WINDOW ASSEMBLY using the SS-214
1)Open the SS-214. Use the guiding on top and
bottom side to position the TOUCH WINDOW
SUPPORT PLATE ASSEMBLY correctly into the SS-214.
Then remove the protective film from the assembly.
2) Remove potective film from the TOUCH WINDOW
ASSEMBLY before placing the assembly. Use the
guiding on bottom side to position the assembly
correctly.
3) Then place the top side of the TOUCH WINDOW
ASSEMBLY using the guide of the SS-214.
4) Close the SS-214 and keep it closed at least 3
seconds to activate the adhesive.
19
Confidential • Copyright © 2010 Nokia • All rights reserved
Version 7.0
Nokia 5530 XpressMusic RM-504
Service Manual Level 1&2
12. SOLDER COMPONENTS
11B
TOP
X2500
S2505
X2501
X2450
X2470
BOTTOM
S2401
F2000
S2500
Ver. 2.0
20
Confidential • Copyright © 2010 Nokia • All rights reserved
Version 7.0