1
Download Document
Transcript
D A T A S H E E T NEVO O600 SERIEES ‐ Modular ‐ Configurrable 600 wa att in the pa alm of your hand NEVO 600 is a modular and uuser configurabble power suppply offering unrivalled perfor mance and flexxibility. Deliveering up to 6000 watts The m a 600 gram 55” x 3” x 1U paackage, the NEEVO is the ultim mate power so olution for app plications where size and weiight are vital faactors. from h system consissts of an input module togethher with up to eight isolated output module es. The series ccarry full UL600950 safety appprovals Each and comply with EN N61000‐3, EN6 61000‐4 and EN550022‐B EMC C standards. MAIN FEATURES: 400 watt outpu 4 ut at 120VAC 5 5” x 3” x 1U foo otprint 3 H High power den nsity (25W/in ) ) Industrial appro ovals H High reliability High efficien ncy – up to 89% % Only 0.6kg –– 100W/kg 2 I C control o option Remote current/voltage programming Accurate current sharing Current output siignal 5V V 200mA bias su upply Ro oHS compliant Fie eld configurable e Tw wo year warranty SYSTEM M SPECIFICATIO ONS INSTALLATION I INP PUT ELECTRICALL Param meter AC Input Voltage AC Input Frequency DC Input Voltage Powe er Rating Details e is 100Vrms to Nominal range 240Vrms Contact factorry for 400Hz operation. Standard Inrush h Current See graphs for deratings 600Watts output at 180Vrms input 265Vrms (cold d start) Fusing 5x20 Fast acting Inputt Current Limit Maintains pow wer factor Inputt Current Min 85 47 Typ 50/ 60 120 Max 264 63 Units Hz II IP R Rating IP10 0 Pollution d degree 2 ROH HS Com mpliance 2/95/EC 2002 Material ggroup IIIb (indoorr use only) 600 Wattss 4 Ampss 20 Ampss 5 Ampss RELIABILITY Ampss Componen nt Details d Mag Lev Std Excluding FA AN See individu ual output datasheets See graphs 86 % Idle P Power All outputs fittted and enabled 28 Wattss INPUT Idle P Power 21 Wattss OUTPUT Warranty UVLO O All outputs fittted and Disabled Typical value ffor 300Watts output at 240Vrms input 600Watts output at 180Vrms input Turn on only Over temperature Internally mon nitored. Latching Reliab bility 40°C 80% load d Holdu up Bias Voltage S i g n a l s Bias current 17 mS 78 84 Vrms 115 125 °C 20 2 4.8 5 0 PNP open collector with internal 10k pull down n resistor 8 0 Inhibit voltage Inhibit current 10k ohm input impedance Min Max Units 3.8 FPMH 2 FPMH 1 FPMH 2 Years 21 Power Good voltage Power Good current Global inhibit voltage Global inhibit current 0.99 94V‐‐2 I Installation n category Efficie ency 0.96 Detaails Equipment class FAN Powe er Factor Parrameter Vrms Vdc 89 Details Flam mmability ratiing 370 6 Parameterr 5.2 200 10 15 SAFETY Parameterr FPMH H Isolation Voltage V mA Isolation Clearance V Details Max Units Input to Ou utput Min 4000 Vac Input to Ch hassis 1500 Vac Output to Chassis 250 Vdc Output to Output Primary to Secondary (Reinforced) Primary to Chassis (Basic) Primary to Secondary (Reinforced) Primary to Chassis (Basic) 250 Vdc 20 mA 2 15 V Isolation Creepage 0.2 1.5 mA Leakage Cu urrent Standard: 2 265Vac, 63Hz, 25°C C 7 mm 12 mm 4 mm 1500 3 15 V MECHANICAL 3 mA Parameterr AC_OK voltage 1 4 V Size 29.7mm x 41.0mm 77.7mm x 12 (all external dimensions ± 1.0mm) AC_OK current ‐10 20 mA Weight 360 gram +6 60 gram per output module AC_OK warningg See user manu ual for exceptions mS Mounting Bottom or Siide mounting (See d diagram for details)) 5k ohm input impedance Vox Power Ltd. Unitt 2 Red Cow Interrchange Estate Ballyymount, Dublin 24, Ireland 3 5511 Tel: +353 1 459 11611, Fax: +353 1 633 b: ww.vox‐powerr.com Web 0.6 5 Distributed By: Details mm 2.5 uA DATASHEET D A T A S H E E T NEV VO600 0 SERIIES EMC E Sttandard Leve el Radiated electtric field EN N55011, EN55022, FFCC B Conducted em missions EN N55011, EN55022, FFCC B Harmonic Distortion EN N61000‐3‐2 Com mpliant m m Flicker & Fluctuation 106 kP Pa Electrostatic discharge EN N61000‐3‐3 N61000‐4‐2 EN (1 15kV air, 8kV contacct) Min Max U Units Temperature ‐40 +85 °C C Humidity Relative, non‐con ndensing 5 95 % % Altitude ‐200 5000 Air Pressure 54 Full power ‐20 50 °C C Temperature Derate input and outputs at 2.5%/°C 50 70 °C C Humidity Relative, non‐con ndensing 5 95 % % Altitude (‐200 to 2000m fo or UL60601‐1) Air Pressure ‐200 3000 m m 78 106 kP Pa 45 dBA Noise Level Measured 1m fro om fan intake Shock 3000 bumps at 10 0G (16ms) half sine wave Vibration 1.5G 10 to 200Hz sine wave, 20G forr 15min in 3 axes n random vibration Emissions Emissions Parameter Details Immunity Immunity O p e r a t i o n S t o r a g e ENVIRON NMENTAL Parameter Com mpliant 4 Radiated RFI EN N61000‐4‐3 (10V/m m) 3 Fast Transient burst EN N61000‐4‐4 (4kV) 4 Input line surgges EN N61000‐4‐5 (1kV L‐N N, 2kV L‐E) 3 Conducted RFII EN N61000‐4‐6 (10V) 4 Power Freq. M Magnetic Field EN N61000‐4‐8 (10A/m m) 3 Voltage Dips EN N61000‐4‐11 (EN55 5024) Com mpliant AGENCY APPROVALS A Sta andard Deetails Standard Details IEC C/EN60950‐1 UL6 60950‐1 CSA A‐C22.2 No. 609 950‐1‐03 CE MARK LV VD 2011/65/EU UL file number UL: E316486 CB certificate and repo ort available on req quest Typical Load d Efficiency 0.9 0.88 0.85 0.8 OP2-220V 0.75 OP1-220V Efficiency Efficiency 0.7 0 150 250 350 450 550 650 Wattts Out 140 120 160 180 200 220 240 260 RMS inpu ut Voltage 600 450 400 350 300 80 100 120 140 160 180 Vinrms 200 220 240 260 Power out Power out 600 550 500 Temperature Derating g 650 250 100 Line Dera ating 650 0.83 OP1-400W OP2-400W OP3-400W OP1-500Wout OP2-600Wout OP3-600Wout 0.84 0.85 0.8 0.86 0.81 50 0.87 0.82 OP3-220V Typical Lin ne Efficiency 0.9 0.89 550 500 450 400 350 300 250 -30 -10 Vox Power Ltd. Unitt 2 Red Cow Interrchange Estate Ballyymount, Dublin 24, Ireland 3 5511 Tel: +353 1 459 11611, Fax: +353 1 633 b: ww.vox‐powerr.com Web 10 30 Tem mperature Distributed By: 50 70 9 90 DATASHEET D A T A S H E E T NEV VO600 0 SERIIES MEECHANICAL DIM MENSIONS AND D MOUNTING SSCREWS N - Neatral E - Earth L - Live SC CREWS MH1, MH H2, MH3, MH4, MH5 5 Screw typ pe M4 Tightening Penetration depth Tighten n to 1.5 Nm 4.00mm max including chassis OUTPUT M MODULES x 8 Screw typ pe M3x5, C/Sink, Posi, Stainleess Steel Tightening Penetration depth Tighten n to 0.75 Nm Defined by screw CHASSIS xx 5 Screw typ pe M3x5, C/Sink, Posi, Stainleess Steel Tightening Penetration depth Tighten n to 0.75 Nm Defined by screw FAN x 2 Screw typ pe M3x24 4, C/Sink, Posi, Stain nless Steel Tightening Penetration depth Tighten n to 0.75 Nm Defined by screw SLOT D SLOT C A Airflow SLOT B SLOT A Vox Power Ltd. Unitt 2 Red Cow Interrchange Estate Ballyymount, Dublin 24, Ireland 3 5511 Tel: +353 1 459 11611, Fax: +353 1 633 b: ww.vox‐powerr.com Web Distributed By: D A T A S H E E T NEV VO600 0 SER RIES CONNECTOR RS J1 Circuit 1 2 3 J J1 PINOUTS 39.40 38.30 Details Live Earth Neutrall NE L J2 Circuit 1 2 3 4 5 6 7 8 9 10 11 12 Circuit 1 2 3 4 5 6 REF. Details Power G Good Slot A Inhibit Power G Good Slot B Inhibit Power G Good Slot C Inhibit Power G Good Slot D Inhibit Global Inhibit AC OK +5V 2000mA Bias Supply COM J5 Details ‐Sense +Sense Voltagee Control Currentt Control / Share / O Out COM +5V loccal bias supply J1 38.0 N - Neatral E - Earth L - Live J3 Positivve Output J4 Negativve Output 2 J2 1 15.7 12 11 1 12.5 + Cirrcuit # 1 - J3 J J J5 J4 J 6 1 DET TAILS M MANUFACTUR RER J1 M MOLEX 10013036 MAIN NS INPUT: 3 Pin, 5.0 08mm, with Friction Lock, 18‐24 AWG J2 M MOLEX 511101260 0 GLOB BAL SIGNALS: 12 Pin n, 2mm, with Frictio on Lock, 24‐30 AWG G J3/4(1) V VARIOUS OUTP PUT POWER TERMIN NAL: TAB SIZE 6.35m mmx0.8mm J5 M MOLEX OUTP PUT SIGNALS: 6 Pin,, 1.25mm, with Fricttion lock, 28‐32 AW WG 051021060 00 Notes 1. Terminal and W Wire current rating must exceed maxim mum short circuit ou utput current. Eg. O Output 1 = 25A*1.25 5 = 31.25Amps 2. Direct equivaleents may be used fo or any connector paarts 3. All cables mustt be rated 105°C min, equivalent to UL1015 TERMINAL 0008701031 0503948051 VARIOUS 0500588000 PART T NUMBERING G SYSTEM NEVO P Power series Leakagee Current NEVO 60 00 S ‐ 1 1 2 3 3 ‐ 0 0 0 Factory Use Use ‘0’ for un nused slots. Blanking platees will be S – Stan ndard inserted at factory Slot A –– Output # Slot D – Output # Slot B –– Output # Slot C – Output # When initially o ordering non‐nomin nal voltage settings add “ /Voltage” aftter each output # w where a special voltaage setting is requirred E.g. If 3.30Vdc is required in slo ot B and all other slo ots require nominal voltages then use:: NEV VO 600S – 1 – 1/3.3 30 – 2 ‐ 3 hat can be used for aall future orders of the same configuraation The factory will tthen issue a 3 digit code for your speciific configuration th When o ordering an input un nit with no outputs inserted, simply ord der NEVO 600S Vox Power Ltd d. reserves the right to change or improve any part of the specificattion, electrical or mech hanical design or manu ufacturing process with hout notice. Please con nsult your local distribu utor or contact Vox Pow wer to ensure that you have the latest specification n before using your pro oduct. For other inform mation relating to the u use of the product pleaase refer to the latest N NEVO user manual. Vo ox Power reserves the rright to make changes without notice to ducts. Vox Power does not assume any liabilitty arising out of the use or application of anyy of its products and off any information to the maximum extent perrmitted by law. No liceense, express or implied, by estoppel or any of its prod otherwise, to aany intellectual properrty rights is granted by this document or by aany conduct of Vox Pow wer. VOX POWER DISCLAIMS ALL WARRANTIES AND REPRESENTATIONS. IN PARTICULAR A ALL OTHER WARRANTIES, CONDITION OR TERMS REL LATING TO SUITABILITYY, FITNESS FOR PURPO OSE, MECHANTABILITY OR CONDITION OF THE PRODUCTS AND WHETHER EXPRESS OR IMPLIED BY STATURE OR COMMON LAW OR OTTHERWISE ARE EXCLUD DED. Document D DOC6001 rev 06 Vox Power Ltd. Unit 2 Red Cow Inteerchange Estate Ballymount, Dublin 24, Ireland 33 5511 Tell: +353 1 459 11661, Fax: +353 1 63 Weeb: ww.vox‐poweer.com Distributed d By:
