Download REF AMP OM
Transcript
Reference Series 5350a 5,3 CHANNEL POWER AMPLIFIER SERVICE MANUAL Infinity Systems, Inc. 250 Crossways Park Dr. Woodbury, New York 11797 Released 2007 Discontinued XXXX Rev0 8/2007 5350a Reference Series - CONTENTS BASIC SPECIFICATIONS ………………..……….……..1 DETAILED SPECIFICATIONS ………….…..…….……..2 PACKING……………………….……………..……………3 APPLICATIONS……………………………………………4 INSTALLATION/SETUP…………………………...…...…5 BASIC TROUBLESHOOTING..…….…….………………5 EXPLODED VIEW/PARTS LIST………………………....6 AMPLIFIER BLOCK DIAGRAM……………………..……7 P.C.B. DRAWINGS….………………………………..……8 ELECTRICAL PARTS LIST ……………………………. 11 IC/TRANSISTOR PINOUTS..…………………………….17 SCHEMATICS……………….……..…………..……..…..18 Reference 5350a Basic Specifications Output Power: (14.4 VDC) 50W RMS x 4 channels plus 150W RMS x 1 channel at 4 ohms ; ≤1% THD 60W RMS x 4 channels plus 300W RMS x 1 channel at 2 ohms ; ≤1% THD Signal-to-noise ratio: 85dBA (reference 1W into 4 ohms) Dynamic power: 89W x 4 and 332W x 1 at 2 ohms Effective damping factor: 6.3 @ 4 ohms Frequency response: 10Hz – 100kHz (-3dB) Maximum input signal: 6.0V Maximum sensitivity: 100mV Output regulation: 0.12dB @ 4 ohms Dimensions (L x W x D): 16-9/16" x 9" x 2-11/16" (421mm x 229mm x 69mm) Fuse: 2 x 40A Infinity continually strives to update and improve existing products, as well as create new ones. The specifications and details in this and related JBL publications are therefore subject to change without notice. 1 5350a Reference Series INFINITY REFERENCE 5350a AMPLIFIER SPECIFICATIONS TEST VOLTAGE 14.4 +0.1V Specification Rating Unit Power Output 4ohm loads @ (stereo mode) for each ch @<1.0%THD (Unit:W)(LPF=22K) ≥50W x 4 + 150W x 1 Watts Power Output 2ohm loads @1kHz/50Hz (stereo mode) for each ch @<1.0%THD (Unit:W)(LPF=22K) ≥75W x 4 + 300W x 1 Watts ≥150W x 2 Watts THD Power 4 ohm loads and 1MD@Reference (Unit:%) LPF=22K ≤0.5% @1kHz/50Hz % THD Power 2 ohm loads and 1MD@Reference (Unit:%) LPF=22K ≤0.5% @ 1kHz/50Hz % ≤0.5% @1kHz % Power Output Bridged (Stereo) Mode 4ohm loads 1kHz @<1.0%THD (Unit:W)(LPF=22K) THD Power 4 ohm loads Bridged (Stereo) Mode (Unit:%) LPF=22K Remarks Channel Separation @full rated power (+80KHZ) @1kHz ≥45dB Full rated power Distortion 1kHz/50Hz LPF=22KHz ≤0.1% % Signal/Noise Ratio a: 1 watt into 4 ohms b: full rated power (dB) >85 >100 dBA 1V signal input 100mV-6V Volts ±20% 10Hz~100kHz; 10Hz~200Hz Hz -3dB High-Pass Crossover Frequency limits +20% 32Hz – 320Hz Hz Low-Pass Crossover Frequency limits +20% 32Hz – 320Hz; 20Hz – 200Hz Hz 0~6dB dB ±1dB Idle Current ( @ 4ohm) 1.9A A ±0.15A MAX current: rated power (All channel 2 ohm load) ≤75A A ≤30mV >200 6.395 850W 0.03dB ON 5V OFF 4V 2 to 3 mV Watts dB Volts Sec 85 ±5 deg C Yes 8~16V 16-9/16" x 9" x 2-11/16" (361mm x 229mm x69mm) 40A x 2 Inches mm A Input Sensitivity Low Level Input(v) @:full rated power Frequency response (Unit:-3dB) Bass Boost:(Unit:dB) @50Hz (±5Hz ) DC Offset: Damping Factor (4ohm): Effective damping factor (4ohm): Dynamic Power @ 2 ohms Output Regulation @ 4 ohms Remote Operating Voltages: Turn on delay time Circuit Protection a. Temperature b. Speaker Short Circuit c. Operating Voltage Range Dimensions (L x W x H): Fuses 2 ±1V +0.5V 5350a Reference Series PACKAGING Item 1 2 3 4 5 6 7 Part Number Description CH5082901201 REF5350a Outer Carton REF5350a Amplifier Plastic Bag Packing Foam Owner's manual Plastic Bag Accessory kit consisting of: Mounting Screws SPARE 40A FUSES Remote Level Control (RJ11) control cable BZL279112001 Visit Infinitysystems.com LS1CJ0402507 1601-403E-00 REMOTE REF AMP 2100-0009-04 3 Qty 1 1 1 1 1 1 1 4 2 1 1 5350a Reference Series APPLICATIONS – 5350a The 5350a can be configured for 5-channel or 3-channel operation, as shown in Figures 9 and 10. To Head Unit Front To Head Unit Rear INPUT MODE SWITCH: • Use INT (internal mode) to send a signal from the front and rear inputs to the subwoofer. • Use EXT (external mode) when sending a dedicated signal to the subwoofer inputs; e.g., if your source unit has a subwoofer output. Figure 9. 5350a connected to four satellite speakers and a single subwoofer. Note crossover and channel assignment settings. NOTE: If head unit has only two preamp outputs, do not connect to rear, and place rear input source switch in the FRONT position. NOTE: Minimum speaker impedance for stereo operation is 2 ohms. Minimum speaker impedance for bridged operation is 4 ohms. Minimum impedance of any subwoofer or combination of subwoofers is 2 ohms. NOTE: If head unit includes a separate subwoofer output, connect it here and place switch in EXT position. Rear Speakers Front Speakers Subwoofer To Head Unit Front Output Figure 10. 5350a connected in bridge (3-channel) mode to a pair of satellite speakers and a subwoofer. Note crossover and channel assignment settings. NOTE: If head unit includes a separate subwoofer output, connect it here and place switch in EXT position. Left Speaker Right Speaker Subwoofer 4 5350a Reference Series INSTALLATION AND SETUP Refer to the illustrations on the previous pages for control location. Reconnect the (–) negative lead to the vehicle’s battery. Apply power to the audio system and play a dynamic music track. SETTING THE CROSSOVER(S) Determine your system plans and set the crossover-mode switch accordingly. If your system design does not include a subwoofer, set the crossover mode to FULL and skip to “Setting Input Sensitivity.” If your system includes a subwoofer, set the crossover mode to HP (high-pass) for your full-range speakers. Adjust the crossover frequency to limit bass, and provide increased system volume with less distortion. Mode Switch: Full: Allows a full-range signal through to the speakers; can be used with larger full-range speakers such as 6" x 9"s. HP: Allows a high-pass signal through to the speakers; should be used with most loudspeakers (can protect your full-range speakers from being overdriven with low frequencies, one cause of speaker damage). LP: Allows only bass to pass through to the speakers; should be selected when powering subwoofers. High-Pass Filters: Initially set the crossoverfrequency control midway. While listening to music, adjust the crossover for the least perceived distortion from the speakers, allowing them to reproduce as much bass as possible. TROUBLESHOOTING SETTING INPUT SENSITIVITY 1. Initially turn the INPUT LEVEL control(s) to the minimum (counterclockwise) position. 2. On the source unit, increase the volume control to 3/4 volume. Slowly increase the INPUT LEVEL control(s) toward three o’clock until you hear slight distortion in the music. Then reduce the INPUT LEVEL slightly until distortion is no longer heard. Route the cable behind the dash or other interior panels and under the carpet. Do not route the cable outside the vehicle. Connect the RJ11 cable between the RJ11 receptacle on the amp and the receptacle on the REMOTE LEVEL control (Figure 12). • PROBLEM: No audio (POWER LED is off). Figure 12. REMOTE LEVEL control electrical connection. • PROBLEM: No audio (PROTECT LED glows red). NOTE: After the source unit is on, blue LEDs (on the top panel) will light, indicating the amplifier is on. If not, check the wiring, especially the remote connection from the source unit. Also refer to “Troubleshooting.” CAUSE and SOLUTION: No voltage at BATT+ and/or REM terminals, or bad or no ground connection. Check voltages at amplifier terminals with VOM. CAUSE and SOLUTION: DC voltage on amplifier output. Amplifier may need service; see enclosed warranty card for service information. • PROBLEM: No audio (PROTECT LED glows red). CAUSE and SOLUTION: Amplifier is overheated. Make sure amplifier cooling is not blocked at mounting location; verify that speaker-system impedance is within specified limits. REMOTE LEVEL CONTROL The 1300a, 1600a and 5350a include a remote level control. This will allow the subwoofer level to be adjusted from the listening position. Connect the remote level control using the RJ11 jack on the side of the amplifier. Install the control module in the front of the vehicle within easy reach of the driver. Both the underside of the dash and the center console are suitable locations. • PROBLEM: No audio (PROTECT LED glows red). CAUSE and SOLUTION: Voltage less than 9V on BATT+ connection. Check vehicle charging system. • PROBLEM: No audio (PROTECT LED glows red). CAUSE and SOLUTION: Voltage greater than 16V or less than 8.5V on BATT+ connection. Check vehicle charging system. UNDER-DASH MOUNTING Select a mounting location that allows easy access to the control while driving. Using the REMOTE LEVEL control as a template, mark and drill holes in the mounting surface. Attach the REMOTE LEVEL control using the mounting screws provided (Figure 11). • PROBLEM: Distorted audio. SETTING THE BASS BOOST The Bass Boost control will allow you to enhance the bass output of your system at 50Hz up to 6dB. Figure 11. Under-dash mounting of the REMOTE LEVEL control. AUX OUTPUT Reference amplifiers (except 5350a) are equipped with full-range outputs that can be used to connect additional amplifiers. Low-Pass Filters: For subwoofers, choose the highest frequency that removes vocal information from the sound of the subwoofer. STATUS LEDs Power: Indicates the amplifier is on. Protection: Refer to “Troubleshooting” for specific indications. If using the 475a to drive a subwoofer(s), set the crossover mode to LP (low-pass) on the channels connected to the subwoofer. Figure 13. LED status. NOTE: The 1300a, 1600a and the subwoofer output of the 5350a are low-pass only and do not have a crossover-mode switch. 5 CAUSE and SOLUTION: Input sensitivity is not set properly, or amplifier or source unit is defective. Check INPUT LEVEL setting, or check speaker wires for shorts or grounds. • PROBLEM: Distorted audio (PROTECT LED glows intermittently). CAUSE and SOLUTION: Short circuit in speaker or wire. Remove speaker leads one at a time to locate shorted speaker or wire, then repair. • PROBLEM: Music lacks “punch.” CAUSE and SOLUTION: Speakers are not connected properly. Check speaker connections for proper polarity. 5350a Reference Series Item# 6 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 Part Number Description SG-0017-2601 GD-600021400 LSIFM0300011 SR-F555-0117 Top cover Light panel Screw Main heat sink Main PCB Front panel Screw for terminal, RCA jacks Screw for F/RP Knob Screw Screw Bottom plate Screw Transistor spring clip (2) Space Pole Transistor spring clip (1) Rear panel Screw Screw LED lens LED PCB MK-0006-2601 LS5KJ0301007 LS5KP0300807 XN-10500-012 LSIAP0300607 LSIAM0300607 XG-0018-2601 LSIAY0301201 PL-L0007-000 ZL-10037A-15 PL-L0006-000 HG-0007-2601 LSIAA0200501 LS1AM0250401 CP-B00011400 Qty 1 1 6 1 1 1 7 8 7 6 2 1 2 8 2 6 1 1 4 1 1 5350a Reference Series 1 2 D INPUT FL 3 4 MODEL FREQ VARIABLE LP 32HZ--320HZ/12dB BALANCED INPUT UNIT MAIN AMP FL 5 6 MODEL FREQ VARIABLE LP 32HZ--320HZ/12dB BALANCED INPUT UNIT 2ohm/4ohm INPUT FR GAIN CONTROL GAIN CONTROL 11 OP 32 320 80K 8 7 OP 11 32 MAIN AMP FR 2ohm/4ohm D 320 80K AMP OP AMP OP SPEAKER SPEAKER BTL-4ohm BTL-4ohm SPEAKER SPEAKER C MODEL FREQ VARIABLE LP 32HZ--320HZ/12dB BALANCED INPUT UNIT INPUT RL MAIN AMP RL 2ohm/4ohm INPUT RR MODEL FREQ VARIABLE LP 32HZ--320HZ/12dB BALANCED INPUT UNIT GAIN CONTROL GAIN CONTROL 11 OP 32 320 80K OP 11 32 C 2ohm/4ohm 320 80K OP OP AMP AMP OP OP MAIN AMP RR SPEAKER SPEAKER OP OP OP OP B B +VAMP1 +VOP INPUT SUB2 MODEL FREQ VARIABLE LP 11HZ--200HZ/12dB BALANCED INPUT UNIT BASS BOOST VARIABLE 0dB--6dB/50HZ MAIN AMP SUB +V2 +V1 2ohm/4ohm + Battery +VAMP2 POWER SUPPLY -VAMP2 11 OP 20 200 11 50 200 -V1 AMP OP -V2 -VOP GAIN CONTROL INPUT SUB1 -VAMP1 BALANCED INPUT UNIT SPEAKER OP A A ECN NO DESCRIPTON APPROVED DW GNO: DATA PART NO: PART NAME: 1:1 DRAWN BY: BLOCK DIAGRAM UNIT: MM CHECKED BY: DATA: PRODUCT MODE: A4 APPROVED BY: DATA: REF5350a 1 2 3 4 5 7 6 SCALE: SIZE: REV: JING HUI CHEN DATA: 1.0 7 8 2007.1.25 5350a Reference Series 8 5350a Reference Series 9 5350a Reference Series 10 5350a Reference Series REFERENCE 5350a Electrical Parts List Part Number Description Qty Reference Designator Main PCB Resistors 0701-35R6-02 Resistor SMD 5.6Ω 1/4W ±5% 1206 6 0701-2220-02 Resistor SMD 22Ω 1/8W ±5% 0805 20 0701-2470-02 Resistor SMD 47Ω 1/8W ±5% 0805 8 0701-2680-02 Resistor SMD 68Ω ±5% 0805 8 0701-2750-02 Resistor SMD 75Ω ±5% 0805 4 0701-2101-02 Resistor SMD 100Ω 1/8W ±5% 0805 22 0701-3101-02 0701-2331-02 0701-2471-02 0701-2681-02 0701-2751-02 Resistor Resistor Resistor Resistor Resistor SMD 100Ω 1/4W ±5% 1206 SMD 330Ω 1/8W ±5% 0805 SMD 470Ω 1/8W ±5% 0805 SMD 680Ω 1/8W ±5% 0805 SMD R0805 750Ω 1/8W ±5% TR 2 1 5 2 1 0701-2102-02 Resistor SMD 1KΩ 1/8W ±5% 0805 53 0701-2222-02 0701-2272-02 0701-2302-02 Resistor Resistor Resistor SMD 2.2KΩ 1/8W ±5% 0805 SMD 2.7KΩ 1/8W ±5% 0805 SMD 3KΩ 1/8W ±5% 0805 4 4 5 0701-2332-02 Resistor SMD 3.3KΩ 1/8W ±5% 0805 13 0701-2392-02 Resistor SMD 3.9KΩ ±5% R0805 TR 10 0701-2472-02 0701-2512-02 0701-2562-02 Resistor Resistor Resistor SMD 4.7KΩ 1/8W ±5% 0805 SMD 5.1KΩ 1/8W ±5% 0805 SMD 5.6KΩ 1/8W ±5% 0805 3 3 1 0701-2682-02 Resistor SMD 6.8KΩ 1/8W ±5% 0805 10 0701-2103-02 Resistor SMD 10KΩ 1/8W ±5% 0805 50 0701-2822-02 Resistor SMD 8.2KΩ 1/8W ±5% 0805 5 0701-2123-02 Resistor SMD 12KΩ 1/8W ±5% 0805 8 0701-2133-02 Resistor SMD 1/8W 13KΩ ±5% 0805 1 0701-2153-02 Resistor SMD 15KΩ 1/8W ±5% 0805 12 11 R152E R154E R153E R155E R166E R167E R135A R135B R135C R135D R135E R136A R136B R136C R136D R136E R137A R137B R137C R137D R137E R138A R138B R138C R138D R138E R152A R152B R152C R152D R154A R154B R154C R154D R150A R150B R150C R150D R151A R151B R151C R151D R101A R101B R101C R101D R9 R13 R43 R44 R52 R52A R53 R53A R54A R56 R56A R57 R57A R58A R114 R214 R314 R414 R100A R110B R110C R110D R170E R169E R65 R46 R161A R161B R161C R161D R150E R151E R148E R114A R114B R114C R114D R139A R139B R139C R139D R139E R140A R140B R140C R140D R140E R210 R310 R410 R146A R146B R146C R146D R146E R149A R149B R149C R149D R149E R133A R133B R133C R133D R133E R115A R117A R116A R115C R116C R117C R143A R143B R143C R143D R143E R11A R12 R14 R15 R102A R102B R102C R102D R112A R112B R112C R112D R132 R18 R19 R20 R145 R145A R145B R145C R145D R145E R148A R148B R148C R148D R141A R141B R141C R141D R141E R142A R142B R142C R142D R142E R7 R32A R47 R48 R49 R50 R66 R21 R22 R107A R107B R107C R107D R109A R109B R109C R109D R34 R35 R36 R37 R38 R39 R40 R102 R103 R104A R104B R104C R104D R105 R105A R105B R105C R105D R106 R106A R106B R106C R106D R108A R108B R108C R108D R113A R113B R113C R113D R133 R202 R203 R205 R206 R302 R303 R305 R306 R402 R403 R405 R406 R21A R134A R134B R134C R134D R134E R160A R160B R160C R160D R160E R20A R30A R202A R203A R302A R303A R402A R403A R41 R27 R30 R163A R163B R163C R163D R163E R164A R164B R164D R164E R164C 5350a Reference Series Part Number Description Qty Reference Designator Main PCB 0701-2223-02 Resistor SMD 22KΩ 1/8W ±5% 0805 0701-2393-02 0701-2473-02 0701-2563-02 0701-2623-02 0701-2182-02 0701-2104-02 0701-2124-02 0701-2224-02 0701-2474-02 0701-2105-02 0701-54R7-02 0702-3220-02 0704-7101-02 0702-7471-02 0712-7221-02 Resistor Resistor Resistor Resistor Resistor Resistor Resistor Resistor Resistor Resistor Resistor Resistor Resistor Resistor Resistor SMD 39KΩ 1/8W ±5% 0805 SMD 47KΩ 1/8W ±5% 0805 SMD 56KΩ 1/8W ±5% 0805 SMD 62KΩ 1/8W ±5% 0805 SMD 1.8KΩ 1/8W ±5% 0805 SMD 100KΩ 1/8W ±5% 0805 SMD 120KΩ 1/8W ±5% 0805 SMD 220KΩ 1/8W ±5% 0805 SMD R0805 470KΩ 1/8W ±5% TR SMD 1MΩ 1/8W ±5% 0805 SMD 4.7Ω 1/2W ±5% 2512 1/2W 22Ω ±5% TR 12.5MM 3W 100Ω ±5% TR 3W 470Ω ±5% 3W 220Ω ±5% 10MM 07051515X102 Resistor 5W 0.15Ω*2 ±5% 3PIN 26*5*18MM 1201-1021-03 Variable resistor 1k multi-loop 2.5 9.5*5*9.5mm four joint A50K R0971G2B W=5 KQ L=15MM Potentiometer T=7.5MM M=1MM FREQ Potentiometer B5K double joint KQ L=15mm ±5% LEVEL Resistor SMD 270Ω 1/8W ±5% 0805 1204-5031-18 1204-5021-05 0701-2271-02 R10A R67 R101 R201 R201A R301 R301A 18 R401A R401 R23A R24A R25A R26B R26C R111A R111B R111C R111D 4 R109 R209 R309 R409 4 R16 R17 R28 R2 4 R23 R24 R25 R26 5 R108 R208 R308 R408 R35A 4 R103A R103B R103C R103D 2 R8 R10 1 R1 1 R51 1 R42 1 R45 5 R165A R165B R165C R165D R165E 6 R60 R60A R61 R61A R62 R62A 2 R63A R64A 2 R63B R64B 2 R63 R64 R156A R156B R156C R156D R156E R157E 7 R158E 5 VR100A VR100B VR100C VR100D VR100E 2 VR102F VR102R 2 2 VR101F VR101R R161E R162E C40 C2 C113A C113B C113C C113D C113E C30 C108A C108B C108C C108D C108E C31 C101B C101C C101D C101A C10A C20A C102 C103 C202 C202A C203 C203A C302 C302A C303 C303A C402 C402A C403 C403A C41 C114A C114B C114C C114D C114E C32 C39 C29 C42 C2A C29A C101 C201 C301 C401 C42A C39A C42B C39B C3 C4 C5 C6 C37 C38 C37A C38A C104 C204 C304 C404 C102A C102B C102C C102D C105 C106 C107 C205 C206 C207 C305 C306 C307 C405 C406 C407 C115A C115B C115C C115D C103A C103B C103C C103D C110A C110B C110C C110D C110E C111A C111B C111C C111D C111E C35 C35A C36 C3A Capacitors 06D211054001 06D211056001 06D212256301 Capacitor Capacitor Capacitor 1UF/25V ±20% 5*11mm 105℃ TR 5mm 1UF/50V ±20% 5*11 105℃ 5.0mm TR 2.2UF/50V ±20% 5*11 105℃ 5mm TR 1 6 1 06D211064301 Capacitor 10UF/25V φ5*11mm ±20% 105℃ TR 5mm 10 06D112264302 Capacitor 22uF/25V ±10% 5*11 105℃ 16 06D211074100 06D211076100 06D212264103 06D212274001 06D212276001 06D214779100 06D212285101 06D214786101 06D214789100 06S321006000 06S121026000 Capacitor Capacitor Capacitor Capacitor Capacitor Capacitor Capacitor Capacitor Capacitor Capacitor Capacitor 100UF/25V±20% 6.3*11 105℃ black 5.0mm TR 100uF/50V ±20% 6.3*11 105℃ Black 5MM TR 220uF/25V ±20% 8*12 105℃ Black 5MM TR 220UF/25V ±20% 8*12 105℃ 5mm 220uF/50V ±20% 10*17 105℃ 5MM 470UF/63V ±20% 13*20 Black 5mm 2200UF/35V Φ16*26MM ±20% 105℃ 7.5MM 4700UF/50V ±20% 25*30mm value < 0.04 105℃ 4700UF/63V ±20% φ35*27mm SMD 10pF/50V 0805 NPO ±5% SMD 1000pF/50V 0805 X7R ±10% 1 5 6 4 2 2 4 2 2 4 4 06S322206000 Capacitor SMD 22pF/50V 0805 NPO ±5% 16 06S324706000 Capacitor SMD 47PF/50V 0805 NPO ±5% 4 06S121017000 Capacitor SMD 100PF/100V 0805 X7R ±10% 10 06S321026000 Capacitor SMD 1000pF/50V 0805 NPO ±5% 4 12 5350a Reference Series Part Number Description Qty Reference Designator Main PCB 06S121036000 Capacitor SMD 0.01uF/50V 0805 X7R ±10% 4 06S121047000 Capacitor SMD 104/100V 0805 X7R ±10% 06S322216000 06s128236001 06D3C2247701 06S124736000 Capacitor Capacitor Capacitor Capacitor SMD 220pF/50V 0805 NPO ±5% SMD 823/50V ±10% X7R 0805 224/100V ±5% Brown TR 5mm SMD 0.047uF/50V 0805 X7R ±10% C33 C33A C34 C34A C7 C8 C9 C10 C12 C13 C14 C15 C15A C16 C16A C16B C17 C17A C17B C19 C20 C21 32 C22 C23 C23A C24 C25 C26 C11 C8A C112A C112B C112C C112D C109E C112E 4 C109A C109B C109C C109D 4 C105A C105B C105C C105D 5 C116A C116B C116C C116D C116E 5 C28 C104A C104B C104C C104D 04WY-39AV101 04WY-10BV101 04WY-15BV101 04WY-33BV104 Diode Diode Diode Diode SMD 3.9V DO-213AA 0.5W SMD 10V DO-213AA 0.5W SMD 15V DO-213AA 0.5W 33V DO-35 0.5W 1 1 3 2 04PT-4148-01 Diode SMD 1N4148 DO-213AA 25 04GS-R204-00 04GS-C6A4-00 Diode Diode FR204 2A 400V 52MM TR MIC6A4 4 1 03T1-Z48N-02 MOS Transistor IRFZ48N TO-220 10 03P1-A940-02 03P1-1015-04 Transistor Transistor 2SA940 PNP TO-220 SMD 2SA1015 SOT-23 PNP 3 5 03P1-B647-01 Transistor 2SB647 1A 120V 0.9W PNP TO-92 TR 9 03P1-B649-07 Transistor 2SB649A 1.5A 180V 20W PNP TO-126 1 03N1-1815-04 Transistor SMD 2SC1815 SOT-23 NPN 18 03N1-2073-02 Transistor 2SC2073 NPN TO-220 4 03N1-667A-01 Transistor 2SD667AC 1A 120V 0.9W NPN TO-92 TR 9 03P1-5401-04 Transistor SMD MMBT5401LT1 PNP SOT-23 10 03N1-5551-04 Transistor SMD MMBT5551LT1 NPN SOT-23 10 03N1-SA13-01 03P1-1695-13 03N1-4468-13 03N1-35CW-26 03P1-36CW-26 01JR-4558-08 01NS-393M-08 01NE-5532-08 2601-P817-00 Transistor Transistor Transistor Transistor Transistor Dual Op-Amp IC Comparator Dual Op-Amp Optocoupler MPSA13 0.5A 30V NPN TO-92 TR 2SA1695 PNP TO-3P 2SC4468 NPN TO-3P TIP35CW NPN T0-247 TIP36CW PNP T0-247 SMD NJM4558 SOP-8 SMD LM393M SOP-8 SMD N5532 SOP8 NEC PC817 4 4 3 3 4 4 4 1 1 2 0100-M833-08 Dual Op-Amp LM833 SOP-8 9 01TI-L494-09 2202-1602-05 2202-1620-05 IC Rectifier Rectifier SMD TL494C SO-16 PWM UF1602CT AKA 16/200V TO-220 MUR1620CTA KAD 16A/200V TO-220 1 2 2 Semiconductors 13 ZD2A ZD3 ZD2 ZD4 ZD5 2D9 2D8 D2 D3 D4 D6 D6A D7 D7A D100A D100B D100C D100D D100E D101A D101B D101C D101D D101E D102A D102B D102C D102D D102E D101 D102 D2A D10A D10B D11A D11B D1 Q11 Q12 Q15 Q16 Q22 Q23 Q24 Q26 Q27 Q28 Q20 Q103E Q104E Q7 Q9 Q10 Q18 Q21 Q102A Q102B Q102C Q102D Q102E Q103A Q103B Q103C Q103D Q3 Q1 Q1A Q1B Q1C Q1D Q1E Q2 Q4 Q5 Q11A Q12A Q111A Q111B Q111C Q111D Q111E Q4A Q5A Q19 Q106E Q107E Q105E Q106A Q106B Q106C Q106D Q108A Q108B Q108C Q108D Q108E Q112E Q113E Q112A Q112B Q112C Q112D Q113A Q113B Q113C Q113D Q100E Q101E Q100A Q100B Q100C Q100D Q101A Q101B Q101C Q101D Q105A Q105B Q105C Q105D Q114E Q115E Q117E Q109E Q116E Q110E Q109A Q109B Q109C Q109D Q114A Q114B Q114C Q114D U102A U102B U102C U102D U2 U3 PC1 PC2 U101 U101A U101B U101C U101D U201 U302 U303 U301 U4 D8 D8A D9 D9A 5350a Reference Series Part Number Description Qty Reference Designator Main PCB Miscellaneous 1500-1000-00 1502-0504-00 1400-0012-06 1400-0011-00 1500-0300-01 1333-0203-00 1333-0204-00 1003-1010-08 1004-3000-10 1601-403E-00 1005-5R04-10 1380-0205-00 1380-0203-00 1401-0001-04 1404-0005-00 3000-5350-01 3000-5350-02 05RN-3031-02 Terminal Jack Jack Jack Terminal Switch Switch Inductor HF bead Fuse Inductor Clear Plating golden cross head screw Pitch 2.0MM 5PIN Bend 90 degree double joint 2.54 6PIN 10P8C RJ45 Clear Plating golden cross head screw SSH-22H04-G9 2P2T length:9MM INPUT SOURCE SSH-23D04-2P3T Length:9MM LPF/FULL/HPF SMD 100MH 100MHZ 4A 30UH φ12 φ5 11.5mm 40A 5UH φ23 φ1.0*5 temperature switch JUC-31F85℃ ±5℃ TO-220 2PIN temperature switch JUC-31F65℃ ±5℃ TO-220 2PIN Fuse holder BXS-03 double joint Black 4PIN With 2 jack, up with red dow with white, plating RCA golden φ47 4:13:18 L1=L2=φ1.0*8 4TS S1=S2=φ1.0*5 HF transformer 13TS S3=S4=φ1.0*1 18TS HF transformer φ37 6:11 L1=L2=φ0.8*8 6TS S1=S2=φ1.0*5 11TS Thermal resistor 30K Φ5MM 1 1 1 1 1 1 2 2 2 4 2 1 1 1 CON2 J2 CON4 RJ45 J1 SW101F SW103F SW103R L7 L3 L5 L6 F1 (2PCS - in accessory bag) L1 L2 TH1 TH2 for F1 2 RCA1 RCA2 1 T2 1 1 T1 RH2 Input PCB Resistors 0701-2102-02 Resistor SMD 1KΩ 1/8W ±5% 0805 0701-2680-02 0701-2181-02 0701-2472-02 0701-2562-02 0701-2103-02 0701-2123-02 0701-2153-02 0701-2203-02 0701-2223-02 0701-2303-02 Resistor Resistor Resistor Resistor Resistor Resistor Resistor Resistor Resistor Resistor SMD 68Ω 1/8W ±5% 0805 SMD 180Ω 1/8W ±5% 0805 SMD 4.7KΩ 1/8W ±5% 0805 SMD 5.6KΩ 1/8W ±5% 0805 SMD 10KΩ 1/8W ±5% 0805 SMD 12KΩ 1/8W ±5% 0805 SMD 15KΩ 1/8W ±5% 0805 SMD R0805 20KΩ 1/8W ±5% TR SMD 22KΩ 1/8W ±5% 0805 SMD 30KΩ 1/8W ±5% 0805 0701-2473-02 Resistor SMD 47KΩ 1/8W ±5% 0805 0701-2563-02 0701-2104-02 0701-2154-02 0701-2205-02 Resistor Resistor Resistor Resistor 1204-5031-18 Potentiometer 1204-5021-05 Potentiometer 1204-5041-05 Potentiometer SMD 56KΩ 1/8W ±5% 0805 SMD 100KΩ 1/8W ±5% 0805 SMD 150KΩ 1/8W ±5% 0805 SMD 2MΩ 1/8W ±5% 0805 Four joint A50K R0971G2B W=5 KQ L=15MM T=7.5MM M=1MM LP FREQ B5K double joint KQ L=15mm ±5% BASS LEVEL 9MM R0971G C500K KQ L=15MM T=7.5MM M=1MM ±10% double joint BASS BOOST R110E R111E R124E R507 R607 R116E R134 R102E 1 R101E 1 R129E 1 R123E 2 R108E R109E 2 R107E R122E 2 R112E R113E 1 R132E 1 R118E 5 R501 R601 R701 R119E R114E 2 R702 R703 R117E R115E R121E R502 R503 R505 R506 12 R602 R603 R605 R606 R106E 1 R103E 1 R128E 1 R105E 1 R131E 8 14 1 VR503 1 VR101S 1 VR505 5350a Reference Series Part Number Description Qty Reference Designator Input PCB Capacitors 06S321006000 06S121026000 06S121046000 06D3C2247701 06S322206000 06D346839001 06D211064301 06D212264102 06D212274001 Capacitor Capacitor Capacitor Capacitor Capacitor Capacitor Capacitor Capacitor Capacitor SMD 10pF/50V 0805 NPO ±5% SMD 1000pF/50V 0805 X7R ±10% SMD 0.1uF/50V 0805 X7R ±10% 224/100V ±5% Brown TR 5mm SMD 22pF/50V 0805 NPO ±5% 683/63V ±5%TR 5mm 10UF/25V φ5*11mm ±20% 105℃ TR 5mm 22uF/25V ±20% 5*11 105℃ Black 5MM TR 220UF/25V ±20% 8*12 105℃ 5mm 4 1 4 2 4 4 3 7 2 C130E C504 C604 C704 C102E C131E C132E C18 C27 C103E C104E C505 C506 C605 C606 C105E C106E C107E C128E C101E C133E C129E C502 C503 C602 C603 C701 C702 C703 C501 C601 Transistor Dual Op-Amp Dual Op-Amp optocoupler SMD 2SC1815 SOT-23 NPN LM833 SOP-8 SMD NJM4558 SOP-8 LCR-0202 1 1 3 1 Q3E U501 U101E U102E U103E LCR 1413-0001-00 1505-0609-00 1333-0203-00 Phone jack Pin Switch 1 1 1 RJ11 CON1 SW101E 1404-0003-00 RCA 6P4C RJ11 Black 2.54 6PIN 0.65*0.65 16mm SSH-22H04-G9 2P2T Length:9MM INT/EXT With 2 jack, up with red dow with white, plating golden 1 SUB1 3 White with blue light 5PIN 2.0 UL1007 28AWG L=100mm 2.0 105℃ Red with red ligth Φ3MM 2P Φ3.0MM Blue with blue light SMD 1KΩ 1/2W ±5% 2010 2PIN UL1007 red black 28AWG L=400mm 5mm 2PIN UL1007 red black 28AWG L=40mm 5mm SMD 0.1uF/50V 0805 X7R ±10% Pitch 2.0MM 5PIN Bend 90 degree 8 1 1 1 2 1 1 2 1 LED1-8 Semiconductors 03N1-1815-04 0100-M833-08 01JR-4558-08 2601-0202-00 Miscellaneous LED BOARD 2004-0017-00 2100-0035-05 2000-0017-00 2004-0014-00 0701-6102-02 2102-0155-02 2102-0154-02 06S121046000 1502-0504-00 LED FFC LED LED Resistor FFC FFC Capacitor Jack MECHANICAL GD-600020003 PL-B0007-000 PL-B0006-000 JY218A13A01X DQ6060030306 SR-RA40-0100 JY233A22A001 JY297A22A001 JY264A22A001 ZA-H00040100 Acylic board 334*48*4.0mm Clear Arylic 334*48*0.25mm Astigmatic film+3M double astigmatic paper glue+Alum. Foil Glisten paper 334*48*0.15mm Glisten film+3M double glue Mica with hole 18*13*0.1MM Insulated paper White Φ3MM TW-1 Small Heatsink 25*15*11MM Alum. Extrusion Mica 33*22*0.1mm Mica 97*22*0.1mm Mica 64*22*0.1mm Snap bottom φ7.5 M3.5*4 15 1 1 1 2 2 2 2 4 2 4 LED300 LED100 R1 R2 C1 C2 5350a Reference Series Part Number Description Qty Reference Designator MECHANICAL LS1AM0250401 LS1AA0301501 LS1FJ0200801 LS1CJ0402507 Screw Screw Screw Screw XN-10500-011 Knob XN-10500-012 LS5KJ0301007 LS5KP0300807 LS1AP0300607 LS1AM0300607 KT-200012200 KT-200021300 DQ8069032084 LS1AY0301201 PL-L0007-000 PL-L0006-000 XG-0018-2601 Knob Screw Screw Screw Screw CAP CAP Washer Screw Clipper Clipper Bottom plate HG-0007-2601 Rear plate MK-0006-2601 Front plate KG-100100500 LS1AA0200501 LS1FM0300011 CP-B00011400 GD-600021400 Snap bottom Screw Screw Lens Reflector board SG-0017-2601 Top plate SR-F550-0117 JY436A10A10X JY428A10A10X ZL-A0001A-15 JD-A01970515 Heatsink Insulated paper Insulated paper PC pole Round mat Plating black Zinc 2.5*4 PA3*15 Plating black Zinc KA2*8 Black Zinc T4*25MM Plating Nickel ABS-757Black 11.7*Ф11MM with red arrow Black painting ABS-757Black Ф10.5*9MM with white arrow 3*10MM (Plating Nickel) 3*8MM (Plating Nickel) 3*6MM (Plating Nickel) PM3*6(Plating Nickel) White PVC for RCA Red PVC for RCA Φ6.9*Φ3.2*0.8MM PM3*12MM Plating Black Zinc 30*36*0.8mm flexibility 30*28*0.8mm flexibility 385*182*1.2mm,H1-144 silver paintng 214*70*1.2mm H1-144 silver painting with silkscreen 214*70*1.2mm H1-144 silver painting with silkscreen T07-003-01φ11*φ14*10.8 BlackABS PA2*5(Black Zinc) KM 3*6MMBlack Zinc 40*10.8*5.7mm PC cold grey 10C 340*53.5*13mm Clear Blue PC 420*227*62mm dia- casting aluminum alloy, H1144 silver painting with silkscreen 385*216*61mm extrusion, Hair with painting Red;36*10*1.0mm one side with glue 28*10*1.0mm Red one side with 3M glue φ7.5*φ3.0*6.4mm white LASK-5 Φ5.0*2.0 black EVA 60 one side with glue 16 4 2 2 4 1 7 7 8 6 4 3 3 2 2 8 7 1 1 1 4 1 6 1 1 1 1 1 6 2 7 5350a Reference Series 17 1 2 3 4 5 6 8 7 5350a Reference Series C103A R105A 10K D C102 22U/25V R105 R102 10K C103 22U/25V R114 100 1 3 CH1 1 C106 C104A 6 R104A 10K 1 7 5 lm833 R103A 1.8K VR101FA B20K 3 6.8k 2 4 823 D 6 R109A 6 1 U102AA 4558 U101AB lm833 R102A 2.7K R117A 7 VR102FB 6.8k C50K 5 U102AB LPF 4558 1 HPF 4 R106A 1K SW103FA FLAT 3 C102A 102 22P C105A 473 VR102FA R107A 3 A50K 2 R101A 75 10K R106 10K 3 2 R103 C101 220U/25V U101AA C101A 10U/16V U101A lm833 2 C104 10P CH1 3 3 R101 22K 10K 1 CH1 RCA1B 4 47P 5 22P 2 C105 2 R115A 1K 10K U301A LM833 2 R114A 1 CHA 1K R111A 22K 3 R116A 1K R112A 3K R110A 100 Q1A R113A R108B C C20A 22U/25V RJ45 GND C203A 22U/25V VR101FB B20K U101BA C101B 10U/16V 6 7 5 1 7 9 6.8k 10 U102BA 4558 U101BB lm833 2 R101B 75 C205 R203A R102B 2.7K C102B 102 1 12R109B 6 VR102FD 6.8k C50K 7 5 U102BB 4558 R106B LPF 5 SW103FB FLAT 7 HPF 6 R114B 47K 5 lm833 10K TEM 2SC1815 CH2 +VOP 8 C204 10P U101B 7 R113B 8 C203 22U/25V 6 B R110B 100 8 R201 22K 10K 8 1 C202 10K R202 8 R205 22U/25V R112B 3K Q1B 8 CH2 RCA1A 2 CHB 1K R111B 22K 8 10K R103B 1.8K 22P 823 C105B 473 2 VR102FC R107B 3 A50K 3 R202A 47K R104B 10K lm833 5 C104B 6 C202A RJ45 GND 100 R30A FR1 R105B 10K R214 CH2 22U/25V B C 47K 47K R201A 22K 47P 2SC1815 11 C10A R10A 22K C103B TEM 10K 10K 8 FL1 R20A 4 22U/25V R203 4 4 22P 4 C206 4 R206 10K 4 C201 220U/25V 4 10K U101BC LM833 U102BC TL072 U101C LM833 U301C LM833 -VOP A U101AC LM833 U102AC TL072 ECN NO DESCRIPTON APPROVED DW GNO: DATA PART NO: PART NAME: FRONT PRE 1 2 3 4 5 18 6 SCALE: 1:1 DRAWN BY: JING HUI CHEN DATA: UNIT: MM CHECKED BY: DATA: PRODUCT MODE: SIZE: A4 APPROVED BY: DATA: REF5350a REV: 1.0 7 8 2007.1.25 A 5350a Reference Series 1 2 3 4 5 6 8 7 R108C C103C CH3 R302 3 10K R301 22K C303 22U/25V CH2 10K U201A 2 C304 10P 1 1 2 3 R314 100 SW101FA SW2P2T 2 CH3 3 B20K R101C 75 10K R306 10K C301 220U/25V C306 R105C 10K U101CA lm833 3 R104C 10K 1 C104C 6 1 7 5 R102C 2.7K R103C 3 6.8k C105C 473 823 D 2 4 VR102RA R107C 3 A50K 2 VR101RA lm833 R303 C101C 10U/16V 10K 5 R305 1 C302 22U/25V CH3 RCA2B 4 3 D 22P 2 C305 47P U102CA 4558 U101CB lm833 1.8K 6 R109C 6 1 R117C 7 VR102RB 6.8k C50K 1K 5 LPF 1 U102CB 4558 3 FLAT 4 HPF R106C C102C 102 SW103RA 10K 2 R115C 1K R114C 7 5 R116C 1K R110C 100 22P U301B LM833 6 CHC 1K R111C 22K R112C 3K Q1C R113C R108D 47K C302A R301A 22K C303A 22U/25V RJ45 GND CH4 R303A C403A 22U/25V RJ45 GND U101DA C101D 10U/16V 100 VR101RB B20K 5 6 7 5 R102D 2.7K 9 6.8k R103D 823 C105D 473 2 10 1 12R109D 6 VR102RD 6.8k C50K 7 1.8K LPF 5 5 U102DB 4558 U102DA 4558 U101DB lm833 C102D R403A 7 VR102RC R107D 3 A50K 3 2 R101D 75 FLAT7 R106D 8 HPF 10K 102 SW103RB R114D 6 R111D 22K CHD 1K R112D 3K R110D 100 47K C405 R104D 10K lm833 C104D 1 R402A 47K C402A R401A 22K 4 22P B Q1D R113D 10K 6 C404 10P U201B TEM 7 CH4 5 C406 22P TH2 2 8 +VOP ECN NO DESCRIPTON APPROVED U101CC LM833 2 U102CC 4558 3 U101DC LM833 U102DC 4558 DW GNO: DATA PART NO: PART NAME: -VOP 1 +VOP 4 R406 10K 4 C401 220U/25V 4 A 8 10K 8 lm833 R403 1 65 0C 4 1 2SC1815 8 C403 22U/25V TEM R402 10K R401 22K 10K 8 2 R405 4 C402 22U/25V CH4 RCA2A C 2SC1815 R105D 10K R414 5 6 22U/25V 6 SW2P2T SW101FB 47K RR1 B CH1 TEM 11 RL1 C103D 47P R302A 10K 10K 8 22U/25V 4 C U201C LM833 4 5 19 6 SCALE: 1:1 DRAWN BY: JING HUI CHEN DATA: REAR PRE UNIT: MM CHECKED BY: DATA: PRODUCT MODE: SIZE: A4 APPROVED BY: DATA: REF5350a REV: 1.0 7 8 2007.1.25 A 5350a Reference Series 3 4 5 6 7 C105E 102 C102E R103E 3 3 4 R129E 180 C505 2 R502 R501 22K C503 22U/25V C501 220U/25V 8 22P 1 3 R507 1K 62K R602 SUB A C602 22U/25V 4 R601 22K C603 22U/25V 1K C601 220U/25V SUB2 CH3 R308 62K CH2 7 5 R607 1K R208 6 3 C207 SUB R310 1K 22P R133 TEM 10K 2SC1815 5 VR505A C500K 2 B SUB2 +VOP C407 47K R210 1K SUB2 CH4 R408 62K 6 U302C 4558 U303C 4558 U501C 4558 -VOP 7 4558 U103EC 4558 U303B 5 R410 1K U101EC LM833 SUB2 U102EC 4558 4558 47K R606 A C606 ECN NO DESCRIPTON APPROVED DW GNO: DATA PART NO: 22P PART NAME: 1:1 DRAWN BY: UNIT: MM CHECKED BY: DATA: PRODUCT MODE: SIZE: A4 APPROVED BY: DATA: REF5350a REV: 1.0 SUB PRE 1 Q1E 50 Hz R118E 21K R115E 47K R132 3K R409 U302B 5 U103EA 4558 104 C132E C131E 104 1 3 4558 7 62K C307 1 47K 47K C128E 683 12K 12K U102EB R112E 4558 R119E 22K 47K R117E 10P CH SUB 1K 4558 2 U303A 2 R209 U501B 4558 6 R603 47K A 6 C604 10P SUB B 3 47K R110 4558 22P 5 1K R113E R134 47K 3 22P R605 1K R309 1 22P SUBB 22P U302A 2 R111E 10 VR503D A50K 47K R108 C506 C605 C107 10u/25V C129E 7 U103EB 7 C130E 6 7 12 VR503C A50K R109 SUB CH1 47K R506 9 1K R503 47K B R110E 47K U501A 4558 2 C504 10P SUB B 1 47K 683 22P R505 SUB A C502 22U/25V SUBA R116E 5 R114E20K 4.7K CON4P-1 C C107E R123E 8 C701 22U/25V +VOP 15K 2 4 C R132E 1 8 2 R121E 47K 4 1 U102EA 4558 C106E 683 20-200Hz R107E 10K R128E 100K D 1 3 5.6K 8 SUB B 30K VR503B A50K 3 RJ11 R703 U101EB LM833 VR503A A50K 4 C704 10P 5.6K R109E 4 1 RJ45 GND R122E 10K R105E 150K 2 1 6 8 C703 22U/25V 2SC1815 R124E 1K SUB A R131E 2M 3 8 R702 30K R701 22K LCR R108E 7 5 11 Hz Q3E 6 3 SUB1 10/25V U101EA LM833 R101E 56 4 C702 22U/25V 3 C104E 224 C103E 224 1 4 3 10/25V C133E 2 11 B20K 1K R102E 4 2 VR101SA 47K 2 C101E D 47K 1 SW2P2T SW101EA 2 1 2 3 SUB2 683 R106E 1 SUB 8 8 2 4 1 2 3 4 5 20 6 SCALE: 7 JING HUI CHEN DATA: 8 2007.1.25 5350a Reference Series 1 2 3 4 5 6 +VAMP1 +V1 Q102A 2SB647A R139A 1K D 10U/25V Q101A A06 C110A 101 R146A R134A 10K C109A 221 R141A 3.9K R135A 22 R145A 3.3K R143A 1K R136A 22 Q105A A13 1 R138A 22 R142A 3.9K R156AA 0.15/5W C114A C112A R161A 104 470 3 -VEE C113A 1UF/25V NC SPA R165A 4.7/0.5W R149A C116A 1K C111A 101 Q113A A56 R147A R156AB 0.15/5W 1K VR100A 2 100U/50V Q112A A56 D Q111A 2SC1815 1K R148A 3.3K R137A 22 PROT R152A 47 1K SPA1 CHA Q100A A06 R133A PRO Q109A TIP35C Q106A 2SD667A +VAMP1 D102A IN4148 +VEE C108A R150A 68 8 7 R154A 47 D100A IN4148 D101A IN4148 224M C C R140A 1K C115A R160A Q108A 2SD667A Q114A TIP36C R163A 15K R151A 68 22 8.2K Q103A 2SB647A R164A 15K -VAMP1 -V1 +VAMP1 +V1 Q102B 2SB647A R139B 1K 10U/25V Q101B A06 C110B 101 R146B R134B 10K B C109B 221 R141B 3.9K R135B 22 R136B 22 R145B 3.3K R143B 1K Q105B A13 R142B 3.9K 1 R138B 22 C114B R161B 104 470 R160B 8.2K R147B 1UF/25V NC B SPB R165B 4.7/0.5W 0.15/5W R149B C116B 1K C111B 101 C115B C113B R156BB 1K VR100B 2 3 -VEE R140B 1K C112B 100U/50V Q113B A56 Q112B A56 Q111B 2SC1815 1K R156BA 0.15/5W R148B 3.3K R137B 22 PROT R152B 47 1K SPB1 CHB Q100B A06 R133B PRO Q109B TIP35C Q106B 2SD667A +VAMP1 D102B IN4148 +VEE C108B R150B 68 -VAMP1 R154B 47 Q108B 2SD667A D100B IN4148 Q103B 2SB647A Q114B TIP36C R163B 15K R151B 68 22 D101B IN4148 224M R164B 15K -VAMP1 -V1 -VAMP1 A A ECN NO DESCRIPTON APPROVED DW GNO: DATA PART NO: PART NAME: FRONT AMP PRODUCT MODE: REF5350a 1 2 3 4 5 21 6 SCALE: 1:1 DRAWN BY: UNIT: MM CHECKED BY: DATA: SIZE: A4 APPROVED BY: DATA: REV: 1.0 7 JING HUI CHEN DATA: 8 2007.1.25 5350a Reference Series 1 2 3 4 5 6 +VAMP1 +V1 Q102C 2SB647A R139C 1K CHC 10U/25V Q100C A06 R133C PROT Q109C TIP35C Q106C 2SD667A D Q101C A06 C110C 101 R152C 47 R146C 1K R134C 10K C109C 221 R141C 3.9K R135C 22 R143C 1K R136C 22 Q105C A13 R145C 3.3K R156CA 0.15/5W 1 R148C 3.3K R138C 22 R142C 3.9K C114C R161C 104 470 C113C R147C NC 1UF/25V SPC 1K VR100C 2 R165C 4.7/0.5W R156CB 0.15/5W R149C C116C 3 1K R154C 47 C111C 101 Q113C A56 Q112C A56 C C112C 100U/50V -VEE R137C 22 Q111C 2SC1815 1K SPC1 C108C D100C IN4148 C115C R160C Q108C 2SD667A Q103C 2SB647A Q114C TIP36C R163C 15K R151C 68 22 8.2K R164C 15K -VAMP1 -V1 Q102D 2SB647A R139D 1K R133D PROT Q109D TIP35C Q106D 2SD667A C110D 101 R152D 47 R146D 1K C109D 221 R141D 3.9K R135D 22 R136D 22 Q105D A13 R145D 3.3K R143D 1K R156DA 0.15/5W R138D 22 R142D 3.9K 1 R148D 3.3K C114D C112D R161D 104 470 1K VR100D 2 R140D 1K R160D 8.2K C115D B NC SPD R149D C116D 1K 3 Q112D A56 R147D R165D 4.7/0.5W 0.15/5W R154D 47 C111D 101 Q113D A56 C113D 1UF/25V R156DB 100U/50V -VEE R137D 22 Q111D 2SC1815 1K SPD1 R134D 10K B +VAMP1 D102D IN4148 Q101D A06 +VEE C108D 10U/25V R150D 68 -VAMP1 +VAMP1 +V1 Q100D A06 224M D101C IN4148 C R140C 1K CHD +VAMP1 D102C IN4148 +VEE D R150C 68 8 7 Q108D 2SD667A D100D IN4148 Q103D 2SB647A Q114D TIP36C R163D 15K R151D 68 22 R164D 15K -VAMP1 -V1 224M D101D IN4148 -VAMP1 A A ECN NO DESCRIPTON APPROVED DW GNO: DATA PART NO: PART NAME: 2 3 4 5 22 6 1:1 DRAWN BY: JING HUI CHEN DATA: REAR AMP UNIT: MM CHECKED BY: DATA: PRODUCT MODE: SIZE: A4 APPROVED BY: DATA: REV: 1.0 REF5350a 1 SCALE: 7 8 2007.1.25 1 2 3 4 5 6 8 7 5350a Reference Series D D +VAMP2 Q102E 2SB647A R139E 1K R141E 3.9K R135E 22 R142E 3.9K C114E B R140E 1K Q105E 2073 R169E 100 270 R156EA 0.15/5W C112E 104 R162E 270 2 1K VR100E 100U/50V R166E 4.7 Q111E 2SC1815 1K R158EA 0.15/5W R157EA 0.15/5W C113E 1UF/25V C R147E NC SPE R156EB R170E 100 R158EB 0.15/5W 0.15/5W R165E 4.7/0.5W R157EB 0.15/5W R149E C116E 1K 3 Q113E 5401 Q112E 5401 R161E R148E 750 R138E 22 -VEE R137E 22 R143E 1K R136E 22 R153E 4.7 R146E 30K 3.3K C109E 104 R145 R134E 10K PROT Q116E C4468 RTH2 D102 4148 SPE1 1K Q110E C468 +VAMP2 D102E IN4148 D101 4148 3.3K R145E C Q109E C4468 Q107E 2SC2073 R152E 4.7 1 10U/25V R133E Q106E 2SC2073 C110E 101 Q101E 5551 +VEE C108E CH SUB Q100E 5551 R150E 680 R160E 12K C115E NC C111E 101 R154E 4.7 Q108E 2SD667A Q103E 2SA940 Q104E 2SA940 Q114E A1695 R155E 4.7 R167E 4.7 D100E IN4148 Q115E A1695 Q117E A1695 R163E 15K R151E 680 -VAMP2 ECN NO A DESCRIPTON 224M D101E IN4148 B R164E 15K -VAMP2 APPROVED DW GNO: DATA PART NO: PART NAME: SUB AMP 1 2 3 4 5 23 6 SCALE: 1:1 DRAWN BY: JING HUI CHEN DATA: UNIT: MM CHECKED BY: DATA: PRODUCT MODE: SIZE: A4 APPROVED BY: DATA: REF5350a REV: 1.0 7 8 2007.1.25 A 5350a Reference Series 2 3 PRO1 1 4 5 Q3 2SB649A 6 F1 40A*2 C4 2200U/35V1 L1A 2 J1 2 1 4 C9 3 104 5uH VIN1 PRO2 R16 C6 4.7K C3 R18 3.3K 2.2K R12 2.2K 2SC1815 R28 R26A 8 5 R35 U2A LM393 R43 100 10K L7 1 10K PC2 P817 REM R47 4.7K R36 10K C13 104 8 5.1K R48 ZD3 10V D3 U3B NE5532 7 -VEE -VEE 5 5.1K R17 47K C31 10U/16V R30 15K +VOP R49 1 2 R37 100UH C12 104 ZD2A 3.9V/0.5W C30 2.2U/16V 6 -VOP R50 +VEE 5.1K +VEE IN4148 3 2 SPE1 +VOP 4 4 1 U2B LM393 PC1 P817 2 3 100 2 1 3 C10 104 R44 Q2 2SC1815 R15 2.2K 10K 7 U3A NE5532 VIN1 R46 470 R45 1M R34 470K R31A 1K PROT 220U/25V 4 C11 104 6 R14 2.2K SPD1 56K 56K R27 15K Q7 2SA1015 D R26 104 R42 SPC1 56K +VOP C2 1UF/50V R25 R13 100 47K 2SC1815 SPB1 56K R21 6.8K C8A 4 120K Q12A 220UF/25V C2A Q1 100K R1 Q5 2SC1815 1 ERO R24 C29 R8 DIAG 4 D1 MIC6A4 SPA1 56K Q4 2SC1815 IN4148 POWER L1B C8 104 2200U/35V 2200U/35V R23 PROT 3 R11A 3 2200U/35V C5 8 D2 1 2 3 REM 5uH 2 D C28 473 104 C7 7 D2A R32A 4.7K PROT IN4148 R23A Q5A 2SC1815 62K R35A C R24A R39 10K C14 U4 TL494 R40 C40 10K 1U/25V R66 5.6K C36 R67 102M 22K R3 1K 16 15 14 13 12 11 10 9 TL494 1 2 3 4 5 6 7 8 ERO Q11A 2SC1815 TH1 85 0C Q12 IRFZ48 IRFZ48 1 220U/25V R52 100 2 R6 1K R56 100 R60 22/0.5W R61 22/0.5W R57 100 R41 13K 104 Q16 IRFZ48 4700U/50V 104 3 7 2 6 J2 C35 102M 4 C23 5 4 3 2 1 C38 104 C34 Q15 IRFZ48 C22 SPE1 20K C37 R62 22/0.5W Q10 2SA1015 100U/16V R26C C15 1 R53 100 C SPD1 20K 30UH 6:11 T1 8 R22 6.8K C41 R4 1K R5 1K R26B L5 D8 MUR1620C C33 103M 5 R10 100K R65 330 Q11 Q9 2SA1015 104 R51 220K SPC1 20K VIN1 R38 10K R25A C29A +VAMP1 C32 D4 220U/25V IN4148 R2 47K ZD2 15V/0.5W SPB1 20K R21A 10K D6 IN4148 V2 R9 100 SPA1 20K Q4A 2SC1815 PRO2 PRO1 B+ R7 4.7K +VOP CON2 4700U/50V L6 1 D9 MUR1620CTR 103M 2 30UH V1 -VAMP1 D7 IN4148 C16A C39A 220U/50V ZD8 B +V1 +V1 104 B 33V/0.5W R63B 470/3W R64B ZD9 33V/0.5W C42A 220U/50V 470/3W V2 Q24 IRFZ48 C33A 103M T2 R4A 1K R52A 100 R53A 100 R54A 100 1 R60A 22/0.5W 220U/70V 2 +VAMP2 104 C37A 4700U/63V R6A 1K R56A 100 R57A 100 R58A 100 R61A 22/0.5W Q21 Q27 IRFZ48 Q28 IRFZ48 103M SPE SPD SPC +VOP 104 C19 104 C20 C21 104 104 C26 C27 CON2 OUTPUT 104 C17 104 104 9 C38A 4700U/63V L6A D9A MUR1620CTR 1 C24 C42 220U/25V R20 3.3K 104 C25 104 R64 2 30UH V1 100/3W -VAMP2 D7A IN4148 104 -VOP 104 A -VOP Q20 2SA940 ECN NO DESCRIPTON APPROVED DW GNO: DATA PART NO: PART NAME: 1 SPB SPA C18 220U/25V 15V/0.5W C23A C34A Q26 IRFZ48 C39 C16 15V/0.5W 7 8 R62A 22/0.5W 4:13:18 2SA1015 +VOP R19 3.3K ZD5 4 A -V2 Q19 2SC2073 ZD4 2 R5A 1K R63 C17B 104 -V2 100/3W C15A 6 10 3 C42B R64A 5 8 VIN1 R3A 1K 220/3W 220/3W L5A D8A 1 MUR1620C 30UH C35A IRFZ48 Q23 IRFZ48 R63A 102M Q22 Q18 2SA1015 -V1 +V2 1 D11B FR204 -V1 +V2 104 10 D6A IN4148 104 C16B C39B 220U/70V D10A FR204 D11A FR204 D10B FR204 C17A 2 3 4 5 24 6 SCALE: 1:1 DRAWN BY: POWER UNIT: MM CHECKED BY: DATA: PRODUCT MODE: SIZE: A4 APPROVED BY: DATA: REF5350a REV: 1.0 7 DATA: JING HUI CHEN 8 2007.1.25 5350a Reference Series 1 2 3 4 D D LED300 prol C blue blue blue LED100 power blue 1 2 3 4 5 LED1 LED2 LED3 LED4 R1 1K 1/2W LED5 LED6 LED7 LED8 R2 blue blue blue 1K 1/2W blue C CN5 CON5 C1 104 C2 104 LED BOARD B B ECN NO A APPROVED DESCRIPTON DW GNO: DATA PART NO: SCALE: 1:1 DRAWN BY: UNIT: MM CHECKED BY: DATA: PRODUCT MODE: SIZE: A4 APPROVED BY: DATA: REF5350a REV: 1.0 PART NAME: LED 1 2 3 25 JING HUI CHEN 4 DATA: 2007.1.25 A