Download FP-004 Programmer(EN)H6051E-R
Transcript
FP-004 PROGRAMMER Operation Manual 2008 International Currency Technologies Corporation V. 5.0 Part Number : H6051E-R International Currency Technologies Corp. Contents 1. Specification...........................................................2 2. Installation...............................................................4 2-1. Harnesses Application.....................................4 2-2. Direct Downloading.......................................15 Use of Materials Limitations International Currency Technologies Corporation (ICT) all rights reserved. All materials contained are the copyrighted property of ICT. All trademarks, service marks, and trade names are proprietary to ICT. ICT reserves the right at all times to disclose or to modify any information as ICT deems necessary to satisfy any applicable law, regulation, legal process or governmental request, or to edit, refuse to post or to remove any information or materials, in whole or in part, in ICT's sole discretion. PC to Device..................................................15 2-3. Indirect Downloading.....................................21 PC to FP-004.................................................21 FP-004 to Device...........................................23 2-4. Sensor Calibration........................................28 3. LED Status...........................................................29 Attachment Table......................................................30 1 www.ictgroup.com.tw 1. Specification : Optional 1. Voltage : DC12V~24V 2. Current : 100mA v Transformer Specification : 1. Model: CIL-R2014 2. Input : 100-240V 50/60Hz 0.5A 3. Power Consumption : 1.2W 4. Operating Temperature : 0°C~ 60°C Figure 2 6. Operating Humidity : 0% ~ 85% (RH) 29.0[1.14] 5. Storage Temperature : -20°C~70°C Figure 1 1500±30[59.0] CABLE ARE UL/CSA 1185 18AWG 80°C300V D5.5*2.5*10L TUNING FORK 17.00[0.67] 1.55[0.06] 12.70[0.5] R1 00 0. R5 [0 .00 .19 5] [0.1 .90 Ø3 Ø3.2 0[0.1 3] 6.30[0.25] ] 22.30[0.88] ] .4 [0 30.20[1.18] 11.75[0.46] 3.00[0.12] 41.0[1.61] 76.0[3.0] Unit: mm [inch] The transformer is required in test mode. www.ictgroup.com.tw 2 3 www.ictgroup.com.tw 2. Installation : 2-1. Harnesses Application Model SV7E V series L series S7ER R83 TAO series (TAO-A/V) S7A/V7A L77F UCA series Fortune Table.1 Harnesses Usage Page WEL-RF302 Power & *Data Comm. 8 WEL-RF303 *Data Comm. 9 WEL-RF302 Power & *Data Comm. 8 WEL-RF303 *Data Comm. 9 WEL-RF302 Power & *Data Comm. 8 WEL-RF303 *Data Comm. 9 WEL-RF302 Power & *Data Comm. 8 WEL-RF303 *Data Comm. 9 WEL-RF302 Power & *Data Comm. 8 Model A/V series J series PA7/PV7 S7 PLUS S6 & S7 Harnesses Page 10 WEL-RF401 Power & *Data Comm. WEL-RF303 *Data Comm. 9 WEL-RF401 Power & *Data Comm. WEL-RF303 *Data Comm. WEL-RF401 Power & *Data Comm. WEL-RF303 *Data Comm. WEL-RF401 Power & *Data Comm. WEL-RF303 *Data Comm. WEL-RF401 Power & *Data Comm. *Data Comm. 9 8 WEL-RF303 *Data Comm. 9 WEL-RF302 Power & *Data Comm. 8 WEL-RF303 *Data Comm. 9 WEL-RF303 *Data Comm. WEL-RF302 Power & *Data Comm. 8 WEL-RF401 Power & *Data Comm. WEL-RF303 *Data Comm. 9 WEL-RF302 Power & *Data Comm. 8 WEL-RF303 *Data Comm. 9 WEL-RF302 Power & *Data Comm. 8 WEL-RF303 *Data Comm. 9 4 RS232 to VCCS Converter Board GP-58 I & GP-58 III 10 9 Power & *Data Comm. TAO Light 10 9 WEL-RF302 NBA 10 9 WEL-RF303 *Data Comm. : Data Communication. www.ictgroup.com.tw Table.2 Usage WEL-RF303 *Data Comm. WEL-RF401 Power & *Data Comm. 10 9 WEL-RF303 *Data Comm. WEL-RF401 Power & *Data Comm. 10 9 10 9 WEL-RF303 *Data Comm. WEL-RF401 Power & *Data Comm. WEL-RF303 *Data Comm. 10 9 10 9 *Data Comm. : Data Communication. 5 www.ictgroup.com.tw Table.3 Model NK Harnesses Usage Page WEL-RCC42-K Power & *Data Comm. 11 WEL-RF303 *Data Comm. WEL-RCC42-K K series *Data Comm. WEL-RF303 WEL-RF303 WEL-RF303 WEL-RF303 WEL-RF303 WEL-RF303 WEL-RF303 Power & *Data Comm. *Data Comm. WEL-RCC42-K MH Power & *Data Comm. *Data Comm. WEL-RCC42-K CVD Power & *Data Comm. *Data Comm. WEL-RCC42-K CSD Power & *Data Comm. *Data Comm. WEL-RCC42-K P70/77/85 Power & *Data Comm. *Data Comm. WEL-RCC42-K NV68/NV72 Power & *Data Comm. *Data Comm. WEL-RCC42-K UF series Power & *Data Comm. *Data Comm. WEL-RCC42-K U series 9 ND series Harnesses Usage Page WEL-RF403 Power & *Data Comm. 12 WEL-RF303 *Data Comm. 9 11 WEL-RF303 Power & *Data Comm. *Data Comm. 9 11 9 6 Model KCT 11 9 11 9 Usage Harnesses Page 3TM-RAA251-K1-02 Power & *Data Comm. WEL-RF303 *Data Comm. 9 13 3TM-RAA251-K1-02 Power & *Data Comm. 13 BCA WEL-RF303 *Data Comm. Table.6 Model 9 11 9 9 9 11 13 3TM-RAA251-K1-02 Power & *Data Comm. Coin Dispenser WEL-RF303 *Data Comm. 11 LV77 Harnesses Usage Page WEL-RLV7719 Power & *Data Comm. 14 WEL-RF303 *Data Comm. 9 9 Table.7 11 9 11 9 *Data Comm. : Data Communication. www.ictgroup.com.tw Model Table.5 WEL-RF303 WEL-RCC42-K E series Power & *Data Comm. Table.4 Model Coin Changer Harnesses Usage Page WEL-RCC42-K Power & *Data Comm. 11 WEL-RF303 *Data Comm. 9 *Data Comm. : Data Communication. 7 www.ictgroup.com.tw www.ictgroup.com.tw 8 9 TMT 2*4 BACK VIEW 2 4 6 8 1 3 5 7 PIN 1- BLACK / WHITE.........DC+12V PIN 2- BLACK..............................GND PIN 4- BLACK..............................GND PIN 5- WHITE......................RS232-TX PIN 8- ORANGE..................RS232-RX TMT 2*4 1 2 3 4 5 6 7 8 D-SUB 9M TOP VIEW 1 2 3 4 5 6 7 8 9 JST ELR-04NV 4 3 2 1 WEL-RF303 MH-B5 5 4 3 2 1 3 4 PIN 2- WHITE..............RS232 TX PIN 3- ORANGE..........RS232 RX PIN 5- BLACK......................GND D-SUB 9M (Please refer to *Note) PIN 3- GREEN...............VCC RX PIN 2- YELLOW.............VCC TX PIN 1- BLACK......................GND JST ELR-04NV BACK VIEW 1 2 PIN 5 ORANGE ............ E-PGC1-TO-BA PIN 4 RED ......................E-PGD1-DATA PIN 3 BLACK ..................................GND PIN 2 YELLOW .............................CVCC PIN 1 GREEN ...................E-RESET-BA 2464 22AWG 5C CABLE PIN 1 BLACK.......................................GND PIN 2 RED..........................................CVCC PIN 3 ORANGE......................E-RESET-BA PIN 5 YELLOW................ E-PGD1-DATA 5 PIN 6 GREEN.....................E-PGC1-TO-BA TO BILL ACCEPTOR #WEL-RF302 TMT 2*3 BACK VIEW 2 4 6 1 3 5 TMT 2*3 1 2 3 4 5 6 WEL-RF302 Figure 3 Figure .4 TO PC #WEL-RF303 www.ictgroup.com.tw www.ictgroup.com.tw PIN 1- GRAY....................GND PIN 2- BLACK.............3.3V RX PIN 3- ORANGE..........3.3V TX 10 2 4 11 1 2 3 4 TMT 2*3 TMT 2*3 BACK VIEW 1 2 3 4 5 6 JST ELP-04NV 2 4 6 1 3 5 1. BLACK 2. RED 3. GRAY 4. ORANGE 5. BROWN 6. BLUE 1. BLACK 2. YELLOW 3. GREEN PIN 8- BROWN...............RX1 PIN 7- BLUE....................TX1 PIN 6- YELLOW.............VCC PIN 5- GREEN...........RESET TMT 2*4 BACK VIEW 2 4 6 8 1 3 5 7 2464 26AWG 8C CABLE BLACK WEL-RCC42-K PIN 1- BLACK..................GND PIN 2- RED.......................VCC PIN 3- GRAY................RESET PIN 4- ORANGE....PROGRAM PIN 5- BROWN.................RX1 PIN 6- BLUE......................TX1 PIN 1- BLACK..........GND PIN 2- YELLOW........RX2 PIN 3- GREEN..........TX2 PIN 1- GRAY.................GND PIN 2- YELLOW.............VCC JST ELP-04NV BACK VIEW 1 3 TMT 2*3 BACK VIEW 2 4 6 1 3 5 TMT 2*3 1 2 3 4 5 6 JST ELP-04NV 1 2 3 4 JST ELP-04NV BACK VIEW 1 2 3 4 WEL-RF401 TMT 2*4 PIN 1- BLACK.......................GND PIN 2- GREEN.......................TX2 PIN 3- YELLOW....................RX2 PIN 4- ORANGE........PROGRAM PIN 5- GRAY....................RESET PIN 6- RED...........................VCC PIN 7- BLUE..........................TX1 PIN 8- BROWN.....................RX1 8 7 6 5 4 3 2 1 PIN 4- RED..........PROGRAM PIN 3- BLACK.................RX2 PIN 2- ORANGE..............TX2 PIN 1- GRAY..................GND PCB JACK VIEW 78 56 34 12 Figure.5 Figure.6 www.ictgroup.com.tw www.ictgroup.com.tw 12 13 TMT 2*3 BACK VIEW 2 4 6 1 3 5 6 5 4 3 2 1 3TM-RAA251-K1-02 PIN 1- BLACK...................GND PIN 2- RED........................VCC PIN 3- BROWN.............RESET PIN 4- YELLOW.....PROGRAM PIN 5- GREEN...................RX1 PIN 6- BLUE.......................TX1 PIN 6- GREEN..................RXD PIN 5- YELLOW................TXD PIN 4- BLUE..........PROGRAM PIN 3- ORANGE..........RESET PIN 2- RED......................VCC PIN 1- BLACK..................GND TMT 2*3 6 5 4 3 2 1 TMT 2*3 BACK VIEW 2 4 6 1 3 5 TMT 2*3 3TM-RAA251-K1-02 1 2 3 4 5 6 WEL-RF403 TMT 2*3 PIN 5- ORANGE .......RESET PIN 4- RED ...................VCC PIN 3- BLACK ..............GND PIN 2- YELLOW.............PGD PIN 1-GREEN ...............PGC PH-A5 5 4 3 2 1 5 4 3 2 1 MH-B5 PIN 1- RED.......................VCC PIN 2- BLACK..................GND PIN 3- BROWN.............RESET PIN 4- YELLOW.....PROGRAM PIN 5- GREEN...................RX1 PIN 6- BLUE.......................TX1 6 5 4 3 2 1 Figure.7 Figure.8 www.ictgroup.com.tw www.ictgroup.com.tw 14 PIN 1- RED PIN 4- BLUE PIN 5- YELLOW PIN 6- ORANGE PIN 8- GREEN TMT 2*3 BACK VIEW 2 4 6 1 3 5 1 2 3 4 DCJACK(2.5)M TMT 2*3 1 2 3 4 5 6 1 2 3 4 JST ELP-04NV 2464 22AWG 5C CABLE PIN 1- BROWN PIN 2- BLACK PIN 3- PINK PIN 5- PURPLE PIN 6- WHITE & BLACK PIN 1- BROWN PIN 2- GRAY PIN 3- WHITE JST ELP-04NV BACK VIEW JST XLR-08V 1 2 3 4 5 6 7 8 BACK VIEW 4 3 2 1 8 7 6 5 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 TMT 2*11 PIN 7- BLACK PIN 8- BROWN PIN 9- PURPLE PIN 10- WHITE & BLACK PIN 13- WHITE PIN 14- GRAY TMT 2*11 BACK VIEW 2 4 6 8 10 12 14 16 18 20 22 1 3 5 7 9 11 13 15 17 19 21 PIN 1- ORANGE PIN 2- BLUE PIN 3- YELLOW PIN 4- GREEN PIN 5- RED PIN 6- PINK WEL-RLV7719 Figure.9 2-2. Direct Downloading Device Power Device 2 1 4 3 1 2 3 4 PC 15 <PC WEL-RF303 (Refer to Page.9) WEL-RF303 (Refer to Page. 9) Device> Step 1 : Connection ¤ For BA (SV7E, V series, L series, S7ER, R83, TAO series (TAO-A/V), S7A/V7A & L77F). For Non-BA (UCA series, Fortune) FP-004 Figure.10 WEL-RF302 (Refer to Page.8) WEL-RF303 (Refer to Page. 9) PC Power ¤ For BA (NK, K, E, U, UF Series , NV68/NV72, & P70/P77/P85). For Non-BA (CSD, CVD & MH). Figure.11 WEL-RCC42-K (Refer to Page. 11) FP-004 JST ELP=04NV Power JST ELR=04NV Power www.ictgroup.com.tw <PC Device> ¤ For BA (A/V Series, J Series, PA7/ PV7, S7 Plus, S6, S7, NBA & TAO Light). <PC ¤ For BA (KCT). For Non-BA (Coin Dispenser). For Non-BA (RS232 to VCCS Converter Board & GP-58 I, GP58 III). Figure.12 1 4 3 FP-004 FP-004 JST ELP=04NV Device Power Power Device Power PC 1 2 3 4 Figure.14 3TM-RAA251-K1-02 (Refer to Page. 13) WEL-RF401 (Refer to Page. 10) 2 Device> PC WEL-RF303 (Refer to Page.9) WEL-RF303 (Refer to Page. 9) JST ELR=04NV Power WEL-RF303 (Refer to Page. 9) ¤ For Non-BA (BCA). Figure.15 3TM-RAA251-K1-02 (Refer to Page. 13) ¤ For Non-BA (ND Series). Figure.13 A FP-004 FP-004 WEL-RF403 (Refer to Page.12) PC Device Power Power www.ictgroup.com.tw WEL-RF303 (Refer to Page. 9) Power PC WEL-RF303 (Refer to Page.9) 16 WEL-RF303 (Refer to Page. 9) 17 www.ictgroup.com.tw <PC Device> ¤ For BA (LV77). Figure.16 <PC Device> Step 2 : Launch software FP-003 PLUS / FP-004. Download FP-003 PLUS / FP-004 from http://www.ictgroup.com.tw/ support Step 3 : Use notepad to edit file “FP-004x.INI”. The com port setting varies according to the connection on PC. FP-004 WEL-RLV7719 (Refer to Page.14) Figure.18 Device Power Power PC WEL-RF303 (Refer to Page.9) WEL-RF303 (Refer to Page. 9) ¤ For Non-BA (Coin Changer). Figure.17 WEL-RCC42-K (Refer to Page.11) A Power Device Step 4 : Select the appropriate model under bill acceptor type. FP-004 Figure.19 PC WEL-RF303 (Refer to Page.9) WEL-RF303 (Refer to Page. 9) Power 1. Power must be applied to device after connection. 2. Please refer to BA or Non-BA installation Guides for precise connector locations. www.ictgroup.com.tw 18 19 www.ictgroup.com.tw <PC Device> Step 5 : Retrieve the firmware path. ( Drag the firmware (hex file) into FP-004 window.) Figure.20 2-3. Indirect Downloading: < PC PC FP-004 Device > FP-004 Step 1 : Connection Figure.22 FP-004 Power PC WEL-RF303 (Page. 9) WEL-RF303 (Page. 9) Power must be applied to FP-004 after connection. Step 6 : Download firmware to target through FP-004. Step 2 : Execute FP-004 download tool “FP4DT-exe”. Figure.21 Step 3 : Use notepad to edit file “FP-004x.INI”. The com port setting varies according to the connection on PC. Step 7 : Complete downloading. Figure.23 Firmware is saved in FP-004 now. www.ictgroup.com.tw 20 21 www.ictgroup.com.tw PC FP-004 FP-004 Step 4 : Select the appropriate model under bill acceptor type. Figure.24 Device Step 1 : Connection ¤ For BA (SV7E, V series, L series, S7ER, R83, TAO series (TAO-A/V), S7A/V7A & L77F). For Non-BA (UCA), Fortune. Figure.26 FP-004 WEL-RF302 (Refer to Page.8) Device Step 5 : Choose “Download” and “To Fp004” to proceed program burning. Figure.25 Power ¤ For BA (NK, K, E, U, UF Series , NV68/NV72 & P70/P77/P85). For Non-BA (CSD, CVD & MH). WEL-RCC42-K (Refer to Page. 11) 2 1 4 3 1 2 3 4 Figure.27 FP-004 JST ELP=04NV Device Power JST ELR=04NV WEL-RF303 (Refer to Page. 9) Step 6 : Complete downloading. Firmware is saved in FP-004 now. www.ictgroup.com.tw 22 23 www.ictgroup.com.tw FP-004 FP-004 Device ¤ For BA (A/V Series, J Series, PA7/ PV7, S7 Plus, S6, S7, NBA & TAO Light). Device ¤ For BA (KCT). For Non-BA (Coin Dispenser). For Non-BA (RS232 to VCCS Converter Board & GP-58 I, GP58 III). Figure.28 WEL-RF401 (Refer to Page.10) 2 1 4 3 Figure.30 FP-004 3TM-RAA251-K1-02 (Refer to Page. 13) FP-004 Device JST ELP=04NV Power Device Power 1 2 3 4 JST ELR=04NV ¤ For Non-BA (BCA). WEL-RF303 (Refer to Page. 9) 3TM-RAA251-K1-02 (Refer to Page.13) ¤ For Non-BA (ND Series). Figure.29 Figure.31 FP-004 A FP-004 WEL-RF403 (Refer to Page.12) Device www.ictgroup.com.tw Device Power Power 24 25 www.ictgroup.com.tw FP-004 FP-004 Device ¤ For BA (LV77). Figure.32 WEL-RLV7719 (Refer to Page.14) FP-004 Device Step 2 : Start downloading a new firmware to Device. Step 1: Press and hold the button for at least 3 seconds, and wait until the faceplate LED turns to purple. Step 2: The faceplate LED will flash faster and faster as It’s approaching the end of download progress. Device Power Step 3: After downloading, the faceplate LED will indicate “Green” as successful downloading or “Red” as failed downloading in 3 seconds. ¤ For Non-BA (Coin Changer). Figure.33 Figure.34 FP-004 WEL-RCC42-K (Refer to Page.11) A FP-004 Device Power Note: As downloading the firmware to Device in this mode, PC Tool shows the download progress automatically. 1. Power must be applied to device after connection. 2. Please refer to BA or Non-BA installation Guides for precise connector locations. www.ictgroup.com.tw 26 Step 3 : Complete indirect downloading. 27 www.ictgroup.com.tw 3. LED Status : 2-4. Sensor Calibration Figure.37 Control Button LED Calibrate sensor of the Bill Acceptor with calibration card every time after download can keep high recognition rate. In addition to the regular bill acceptor calibration by connecting to PC, there is another option allows users to calibrate Bill Acceptor after indirect downloading without PC. Please follow the steps below to calibrate BA: 1. After download complete, FP-004 would be back to standby mode, and BA will be in white card calibration mode automatically (LED constantly stays green). Stays Green Flashes Green Figure.35 Table.8 Flashes Flashing Idling FP-004 to Device Mode ON Download Download Successful Blue ON Idling PC to BA RS232 Mode Yellow ON Idling PC to BA Test Mode Flashing Idling Memory Problem Download Download Fail Green BA FP-004 2. Insert white card in BA to calibrate. 3. White card will be rejected when calibrating succeed. Red Figure.36 Purple 4. Restart BA after calibrating www.ictgroup.com.tw 28 Status Mode ON ON Flashing Busy Download Download in Progress t Control Button: 1. Click to switch between PC and Device. 2. Press and hold three seconds to start downloading from FP-004 to Device. 29 www.ictgroup.com.tw Table 1 Attachment Table 2 Table 1 Attachment Table 1 Table.10 Table.9 BA Model Type Models A / V Series for (549) A6, A7, V6, V7 V Series for (PIC33) V7E, V77E E Series for (549) E77 H Series for (549) H77 J Series for (549) J830 K Series for (372) K77 L Series for (PIC33) L70, L83, L70#, L83#, L77F N Series for (549) N6, N7 NK Series for (487) NK77 P Series for (549) P70, P77, P85, PA7, PV7 S Series for (549) S6, S7, S7 PLUS S Series for (PIC33) SV7E, S7ER TAO Series for (PIC33) TAO-A, TAO-V Non-BA Model Type Models Coin Dispenser for (STM8S207) Coin Dispenser RS232 to VCCS Converter Board for (487) RS232 to VCCS Converter Board GP-58 I for (549) GP-58 I GP-58 III for (STM205) GP-58 III BCA for (STM8S207) BCA Ticket Printer for (PIC32) Fortune Coin Changer for (STM32) Coin Changer TAO Light Series for (549) TAO Light U Series for (549) U70, U77, U85 UF Series for (549) B70UF, B77UF, B85UF NV Series for (STM32) NV68/NV72 NBA for (STM32) NBA KCT for (STM8S207) KCT LV77 for (PIC33) LV77 Please contact ICT for any other questions. www.ictgroup.com.tw 30 31 www.ictgroup.com.tw Taiwan International Currency Technologies Corporation Ji-Hong Building, No 24, Alley 38, Lane 91, Nei-hu Rd., Sec. 1, Taipei, Taiwan, R.O.C. Tel: 886-2-2797-1238 ‧ Fax: 886-2-2797-1634 [email protected] (For Sales) [email protected] (For Customer Service) Website: www.ictgroup.com.tw Please visit ICT website for the latest information.