Download Golvo 8000 / 8008
Transcript
Golvo 8000 / 8008 Service Manual English Prod. No. 2000014 2000015 2000019 2000024 2000025 Golvo 8000 Golvo 8008 Golvo 8008 LowBase Golvo 8000 Classic Golvo 8008 Classic Golvo with fixed hand control: Prod. No. 2000034 Golvo 8000 2000035 Golvo 8008 2000039 Golvo 8008 LowBase 3EN400404-02 2012-12-28 Proj. 1728,1707 Golvo 8000 / Golvo 8008 Golvo 8008 LowBase Golvo 8000 Classic / Golvo 8008 Classic © Copyright Liko AB Repairs and maintenance may only be performed by personnel authorized by Hill-Rom/Liko and using original Liko spare parts. For information regarding Service and Maintenance education, contact your Hill-Rom/Liko representative. For contact information please visit our website: www.liko.com Liko AB • Nedre vägen 100 • SE-975 92 Luleå • Sweden tel +46 (0)920-47 47 00 • fax +46 (0)920-47 47 01 [email protected] • www.liko.com Table of Contents Page 1.0 Table of contents..............................................................................3 2.0 Spare Parts Position..........................................................................5 3.0 Technical Data 3.1 Measurments Golvo 8000/8008........................................... 7 3.2 Measurements Golvo 8000 Classic/ 8008 Classic............... 8 3.3 Golvo with IR hand control................................................... 9 3.4 Golvo with fixed hand control.............................................. 10 4.0 Troubleshooting 4.1 Golvo with IR hand control....................................................... 11 4.2 Golvo with fixed hand control..................................................12 4.2 CBL2012 ............................................................................13 5.0 Spare Parts Data (Spare Parts/Golvo model).................................14 5.0 Spare Parts List (Spare Parts information)......................................18 5.12 Emergency Lowering Device Golvo, grey...............26 5.13 Body/Handle set for Emergency Lowering Device .28 5.14 Lift Strap G7 / G8.....................................................30 5.20 Hand control 6-Button..............................................32 5.33 Gear Rack set .........................................................33 5.36 Spring Magazine......................................................35 5.159 Front Fork Cover ....................................................36 5.185 Lift Strap G77 ES / G88 .........................................37 5.250 Reinforcement Plate Golvo......................................39 5.264 Latch Universal Sling bar.........................................40 5.274 Motor for Base Width Adjustment Golvo, grey.........41 5.275 Plastic Housing, grey...............................................42 5.279 Roll Frame Attachment Golvo, grey.........................44 5.280 Base Motor Cover, grey...........................................45 5.284 Front Wheel 75 mm Standard.................................46 5.285 Rear Wheel 75 mm Standard..................................47 5.292 Hook for Hand control..............................................48 5.293 End Cover Handle/Arm Support, grey.....................49 5.294 End Cover Armrest, grey.........................................50 5.311 Latch, composite.....................................................52 5.323-324 Easy Strapper G7 / G8............................................53 5.330 Golvo 7007 / 8008 LowBase kit...............................54 5.333 Wireless Hand control HBL......................................56 5.336 Control Unit by S/N..................................................57 5.336C Control Unit by S/N, Cable......................................59 5.348-349 Extension cable CBL...............................................61 5.350 Extra Battery Box.....................................................62 5.351 Beltclip HBL20.........................................................63 5.352 Clips with hook HBL20............................................64 5.353 Charge Cable Hook.................................................65 5.354 Hand control hanger................................................66 5.397 Q-link.......................................................................67 5.398 Lift strap joint...........................................................69 5.404 Friction plates 2.8-3.4 mm.......................................71 5.411 Control Unit CBL, Golvo..........................................73 5.411C Control Unit CBL, Golvo cable.................................75 5.419 Adapter Golvo (for Scale)........................................77 5.420 Limit Switch Box......................................................78 5.421 Limit Switch PCBA...................................................79 5.422 Locking device CBL20.............................................80 5.423 Actuator G8 / G88....................................................81 5.485 Fork locking attachment..........................................83 5.486 Wheel Fork..............................................................84 5.487 Parking bracket........................................................85 5.490 SlingBar Assembly set.............................................86 5.492, 496 Lift Strap Cover Strip ..............................................87 5.511 Locking Ring CBL....................................................88 6.0 Service, Control Unit CBL 6.1 Parameter Code Key.......................................................... 89 6.2 Reset Service Interval Parameters..................................... 90 7.0 Liko Service System........................................................................91 8.0 Liko Diagnostic System - Service....................................................92 9.0 Periodic Inspection..........................................................................93 10.0 Preventative Maintenance...............................................................97 11.0 Product Changes..........................................................................107 Golvo 8000, Golvo 8008, Golvo 8008 LowBase, Golvo 8000 Classic, Golvo 8008 Classic 1.0 4 www.liko.com Spare Parts Spare Parts Position PROD. NO. PRODUCT PROD. NO. 2000050 Golvo 7000ES Classic 2000061 2000051 Golvo 7007ES Classic PRODUCT Golvo 7007 LowBase 279 492 496 279 492 250 250 185 324 14 185 323 324 275 36 264 12 13 311 275 490 293 36 264 311 487 293 12 13 294 487 139 293 139 11 18 11 19 33 404 19 18 33 251 274 280 404 274 280 251 159 485 486 159 485 486 285 285 160 263 22 23 24 248 160 263 284 22 23 24 248 PROD. NO. PRODUCT 2000019 Golvo 8008 LowBase (intelligent control box) 2000039 Golvo 8008 LowBase (intelligent control box and cable hand control) 279 492 250 397 419 398 490 36 275 12 13 294 490 20 264 311 354 333 351 352 511 354 487 293 422 292 350 336 411 274 280 185 324 420 421 423 33 404 159 485 486 285 330 Doc. No. 3EN800804-01 12 5 www. liko.com www.liko.com 2.0 Spare Parts Spare Parts Position PROD. NO. 2000014 2000015 2000034 2000035 PROD. NO. PRODUCT PRODUCT 2000024 Golvo 8000 Classic 2000025 Golvo 8008 Classic Golvo 8000 (intelligent control box) Golvo 8008 (intelligent control box) Golvo 8000 (intelligent control box and cable hand control) Golvo 8008 (intelligent control box and cable hand control) 279 492 496 (intelligent control box) (intelligent control box) 279 492 496 250 250 14 185 323 324 14 185 323 324 490 490 264 311 264 311 36 275 36 275 354 12 13 354 333 351 352 511 354 294 12 13 487 293 333 351 352 511 354 293 420 421 420 421 422 487 422 350 350 423 423 336 411 411C 336 411 33 404 274 280 274 280 285 33 404 285 159 485 486 159 485 486 284 284 Service Tools, see page 79 397 419 398 490 20 Liko Service System 292 Liko Diagnostic System 348 349 330 Doc. No. 3EN800804-01 13 6 www.liko.com www.liko.com 3.1 Technical Data Golvo 8000 / 8008 Dimensions Top view 700 mm (27.5 in) Lateral view M D C A D2 O Lmax E Lmin EG Golvo LowBase 600 mm (23.6 in) F1 F B3 B2 B1 B B4 Maximum reach Tableofmeasurements Model A C D B1 B2 B3* B4 Golvo 8000 1995 1360 1115 800 435 435 - 938 654 826 Golvo 8008 2090 1455 1185 870 480 480 - 1020 735 Golvo LowBase 2090 1455 1185 870 480 480 600 1028 745 max. min. B (mm) D2* E F F1 G 543 0 975 105 25 840 1735 907 623 0 1100 105 25 940 907 623 0 1100 60 / 105 22 940 max. min. max. min. Lmax Lmin M O 475 440 362 1860 600 436 391 1860 600 436 391 (Inch.) Model A max. min. B B1 B2 B3* B4 C D max. min. max. min. D2* E F F1 G Lmax Lmin M O Golvo 8000 78.5 53.5 43.9 31.5 17.1 17.1 - 36.9 25.7 32.5 21.4 0 38.4 4.1 1.0 33.0 68.3 18.7 17.3 12.8 Golvo 8008 82.3 57.3 46.6 34.2 18.9 18.9 - 40.2 28.9 35.7 623 0 43.3 4.1 1.0 37 73.2 23.6 17.2 15.4 Golvo LowBase 82.3 57.3 46.6 34.2 18.9 18.9 23.6 40.5 29.3 35.7 623 0 43.3 2.4 / 4.1 0.9 37 73.2 23.6 17.2 15.4 The lifting interval 1260 mm (50 inch.) is height-adjustable,.see page 9. Lifting height dimensions are based on the lift being equipped with a standard sling bar and standard wheels. When changing to other lifting accessories, check that the lift still achieves the desired lifting height. * Reference measurement according to Standard EN ISO 10535:2006. 7 Golvo • 7EN140105-02 4 www.liko.com w w w . l i k o . com 3.2 Technical Data Golvo 8000 Classic / 8008 Classic Dimensions Topview 700 mm 700 mm (27.5 in) (27.5 Inch.) Lateralview M D C A D2 O Lmax Lmin EG 600 mm 600 mm (23.6 in) (23.6 Inch.) E F1 F B3 B2 B1 B Maximum reach Tableofmeasurements Model A C D B1 B2 B3* B4 Golvo 8000 1995 1360 1115 800 435 435 - 938 654 826 Golvo 8008 2090 1455 1185 870 480 480 - 1020 735 907 max. min. B (mm) D2* E F F1 G 543 0 975 105 25 840 1735 623 0 1100 105 25 940 1860 max. min. max. min. Lmax Lmin M O 475 440 362 600 436 391 (Inch.) Model A max. min. B B1 B2 B3* B4 C D max. min. max. min. D2* E F F1 G Lmax Lmin M O Golvo 8000 78.5 53.5 43.9 31.5 17.1 17.1 - 36.9 25.7 32.5 21.4 0 38.4 4.1 1.0 33.0 68.3 18.7 17.3 12.8 Golvo 8008 82.3 57.3 46.6 34.2 18.9 18.9 - 40.2 28.9 35.7 0 43.3 4.1 1.0 37 73.2 23.6 17.2 15.4 623 The lifting interval 1260 mm (50 inch.) is height-adjustable,. see page 9. Lifting height dimensions are based on the lift being equipped with a standard sling bar and standard wheels. When changing to other lifting accessories, check that the lift still achieves the desired lifting height. * Reference measurement according to Standard EN ISO 10535:2006. 8 www.liko.com Technical Data Golvo 8000 /Definitions 8008 with IR Hand Control TechnicalData Golvo8000/8008Classic 200 kg (440 lbs) Maximumload: Material: Anodised aluminium Weight: 8000: 42 kg (92 lbs) 8008: 44 kg (97 lbs) 8008 LowBase: 46 kg (101 lbs) 1 Heaviest removable part: 8000: 18 kg (40 lbs) 2 8008: 19 kg (42 lbs) 8008 LowBase: 21 kg (46 lbs) 17 16 Wheels: Operatingforces, controls: 1. Lift Strap HandControlIR: Batteries: 2 AAA LR03 1.5 V, alkaline. 2. Sling bar withReach: latches2 m (78.74 inch.) 3. HandControl24 IR V Electricaldata: 4. Parking panel for sling bar Intermittent Int. Op 10/90, active operation max 2 min. 5. Holder for Quick Guidelength and colour code operation: OnlyReference 10% of a given of time may for sling sizesbe active, yet no more than 2 min. 6. Product decalNiMH cells, 2.2 Ah. New batteries Battery: by the supplier. 7. Lift mast withprovided inbuilt motor 3 15 14 Turningdiameter: 13 12 Front: 75 mm* (3 inch.) twin wheels. *Golvo LowBase: 46 mm (1.8 inch.) twin wheels. Rear: 75 mm4 (3 inch.) twin wheels with brakes 8. Front wheelsCBL20001, built-in, 100-240 V AC, Batterycharger: 50-60 Hz, max 600 mA. 9. Base 5 Golvo 8000: 1240 mm (49 inch.) Golvo 8008: 1330 mm (52 inch.) 6 Golvo 8008 LowBase: 1330 mm (52 inch.) 7 Lift motor: V,brakes 6.5 A 10. Rear wheels 24 with 11. Motor for base-width adjustment Motorforbasewidthadjustment: 24 V,emergency 3.5 A 12. Control box with stop built-in charger and operation panel (electrical emergency lowering/raising) Forward direction Emergency lowering11device: Mechanical and electrical Lifting speed 10 withnoload: Two speeds; 41 mm/s (1.61 inch/s) and 33 mm/s (1.3 inch/s) 9 Lifting interval: 1260 mm (50 inch.) (height-adjustable) Sound level: 52,8 dB(A) Protectionclass: IP X4 Buttons on hand control: 4 N Button on display: 4 N 13. Control box IR receiver The device is intended for use indoors. 14. Battery TypeHandles B, in accordance with the electrical shock 15. 16. Emergency protection class.Lowering (mechanical) 17. Lift arm Class II equipment. 8 Protected by Patent w w w . l i k o . com 3 Golvo • 7EN140105-02 Technical Data Golvo 8000 Classic / 8008 Classic with IR Hand Control TechnicalData Maximumload: 200 kg Electricaldata: 24 V Material: Anodised aluminium Weight: Golvo 8000 Classic: 39 kg (86 Ibs) Golvo 8008 Classic: 41 kg (90 Ibs) Heaviest removable part: Golvo 8000 Classic: 18 kg (40 Ibs) Golvo 8008 Classic: 19 kg (42 Ibs) Intermittent operation: Int. Op 10/90, active operation max 2 min. Only 10% of a given length of time may be active, yet no more than 2 min. Battery: NiMH cells, 2.2 Ah. New batteries provided by the supplier. Batterycharger: CBL20001, built-in, 100-240 V AC, 50-60 Hz, max 600 mA. Liftmotor: 24 V, 6.5 A Motorforbasewidthadjustment: 24 V, 3.5 A Wheels: Turningdiameter: Front: 75 mm* (3 inch.) twin wheels. Rear: 75 mm (3 inch.) twin wheels with brakes Golvo 8000 Classic: 1240 mm (49 inch.) Golvo 8008 Classic: 1330 mm (52 inch.) Emergency loweringdevice: Mechanical and electrical Liftingspeed withnoload: Two speeds; 41 mm/s (1.61 inch/s) and 33 mm/s (1.3 inch/s) Liftinginterval: 1260 mm (50 inch.) (height-adjustable) Soundlevel: 52,8 dB(A) Protectionclass: IP X4 Operatingforces, controls: Buttons on hand control: 4 N Button on display: 4 N HandControlIR: Batteries: 2 AAA LR03 1.5 V, alkaline. Reach: 2 m (78.74 inch.) Golvo Classic • 7EN140106-02 The device is intended for use indoors. Type B, in accordance with the electrical shock protection class. Class II equipment. Protected by Patent 93 www.liko.com w w w . l i k o . com Technical Data Golvo 8000Technical / 8008, with fixed Hand Control Data Maximum load: 200 kg (440 lbs) Material: Anodised aluminium Weight: 8000: 42 kg (92 lbs) 8008: 44 kg (97 lbs) 8008 LowBase: 46 kg (101 lbs) Heaviest removable part: 8000: 18 kg (40 lbs) 8008: 19 kg (42 lbs) 8008 LowBase: 21 kg (46 lbs) Wheels: Turning diameter Operating forces, Buttons on hand control: 2.4 N controls: Button on display: 4 N Front: 75 mm* (3 in) twin wheels. *Golvo LowBase: 46 mm (1.8 in) twin wheels. Rear: 75 mm (3 in) twin wheels with brakes. Mechanical and electrical Lifting Speed no load Two speeds; 41 mm/s (1.61 in/s) and 33 mm/s (1.3 In/s) Lifting interval: 1260 mm (49.6 in) (height-adjustable) Sound level: 52.8 dB(A) Protection class: IP X4 Golvo • 7EN140107-01 24 V Intermittent power: Int. Op 10/90, active operation max 2 min. Only 10% of a given length of time may be active, but no more than 2 min. Battery: NiMH cells, 2.2 Ah. New batteries provided by the supplier. Battery charger: CBL20002, built-in, 100-240 V AC, 50-60 Hz, max 600 mA. Lift motor: 24 V, 6.5 A Motor for basewidth adjustment: 24 V, 3.5 A Golvo 8000: 1240 mm (49 in) Golvo 8008: 1330 mm (52 in) Golvo 8008 LowBase: 1330 mm (52 in) Emergency lowering device: Electrical data: The device is intended for use indoors. Type B, in accordance with the electrical shock protection class. Class II equipment. Protected by Patent 3 w w w . l i k o . com 10 www.liko.com 4.1 Troubleshooting Golvo 8000/8008 with IR Hand control SimpleTroubleshooting Theliftcannotbecontrolled via HandControl IR. 1. Check that the emergency stop has not been activated. 2. Make sure that the charging cable is not connected to an electric outlet. 3. Check if HandControl IR indicates battery change. 4. If the lift has been inactive for 24 hours, enable the system, press optional button on the operation panel. 5. Make sure that the HandControl IR control is enabled. 6. If the problem remains, see “The lift cannot be controlled via the operation panel”, below. Theliftcannotbecontrolled via the operation panel. 1. Make sure that the emergency stop has not been activated. 2. Check that the charger cable is not connected to an electric outlet. 3. Check the battery capacity. 4. Make sure that the cables to the control box are connected correctly. 5. Check that the battery’s contact plates are not defective or broken. 6. If the problem remains, please contact Liko/Hill-Rom. Thechargerdoesn’twork. 1. Make sure that the emergency stop has not been activated. 2. Make sure that the battery is properly attached. 3. Check that the battery pack’s contact plates are not defective or broken. 4. If the problem remains, please contact Liko/Hill-Rom. Theliftisstuckinthehigh position. 1. Make sure that the emergency stop has not been activated. 2. Check the battery capacity. 3. HandControl IR indicates battery change. 4. Use the indicated electrical emergency lowering to lower the patient onto a firm surface. 5. Use the indicated mechanical emergency lowering to lower the patient onto a firm surface. 6. If the problem remains, please contact Liko/Hill-Rom. Theliftdoesnotreachmaximum liftingheight. 1. Check that the lifting interval level is correctly set. 2. If the problem remains, please contact Liko/Hill-Rom. Ifyouhearunusualsounds. Contact Liko/Hill-Rom. 11 www.liko.com 4.2 Troubleshooting Troubleshooting GolvoSimple 8000/8008 with fixed Hand Control The lift cannot be operated with the hand control. 1. Check that the emergency stop button has not been pressed. 2. Check the battery capacity. 3. Check that the charger cable is not connected to an electric outlet. 4. Check that the hand control cable is correctly connected. 5. If the lift works via the operation panel, change the Hand Control. 6. If the problem persists, please contact Liko/Hill-Rom. The lift does not work up/down with the operation panel. The base-width adjustment doesn’t work (in/out) with the operation panel. 1. Check that the emergency stop button has not been pressed. 2. Check that the cables to the control box are connected correctly. 3. Check that the charger cable is not connected to an electric outlet. 4. Check the battery capacity. 5. If the problem persists, please contact Liko/Hill-Rom. The charger doesn’t work. 1. Check that the emergency stop button has not been pressed. 2. Check that the charger cables are connected correctly. 3. Make sure that the battery is properly attached. 4. If the problem persists, please contact Liko/Hill-Rom. The lift is stuck in the high position. 1. Check that the emergency stop button has not been pressed. 2. Check the battery capacity. 3. Check that the hand control cable is connected correctly. 4. Electrical emergency lowering, use the operation panel to lower the patient onto a firm surface. 5. Use the mechanical emergency lowering device to lower the patient onto a firm surface. 6. If the problem persists, please contact Liko/Hill-Rom. The lift does not reach maximum lifting height. 1. Check that the lifting interval level is correctly set. 2. If the problem persists, please contact Liko/Hill-Rom. If any noises are heard. Contact Liko/Hill-Rom. 12 www.liko.com 8 Battery Contract No: Trouble Shooting Troubleshooting Name: 4.3 for CBL20 Address: Tools Required (Zip Code) Note! Begin with Simple trouble shooting from Service manual for the actual product. If problem remains continue as described below. Tools required Multimeter Instructions regarding the check points for Viking M Lift type: Serial No: Prod. Year: Check point: 1. Make sure that: - the8 Battery emergency stop 1 is not activated. - the battery is assembled correctly. - the charging cable is not connected to mains. Contract No: Name: Ah 140 280 420 560 700 Check: Address: Replace: (Zip Code) 2. Check operation panel function´s for actuator and base motor Push control buttons on operation panel 2 at control box Tools required - If both actuator and base motor functions response, continue to step 5. green, LED - If no function, continue to step 3. 2 - If only one of either the actuator or base motor function response: change position on actuator and base motor cables then check control function of operation panel, to see if fault is on output channels or the motors. If control box function is ok! Continue to step 5. If control box is faulty. Replace the control box. 3 yellow, LED 4 3 1 1 Battery capacity Check battery capacity by pressing the i button (1). The following information is displayed: 2 – Green light: More than 50% of battery capacity remaining. 3 – Yellow light: 25% -50% of battery capacity remaining. 4 – Yellow light: 0% -25% of battery capacity remaining. The indicator lamps light for about 30 seconds before switching off. Battery capacity is also displayed during lift operation. 2 3. Check battery capacity 3a) Push in the battery capacity button 3 : - If any of the three LED´s on the battery start´s the battery is OK, continue to step 4. - If not, continue to step 3b. 3b) Measure battery voltage: release battery, 4 measure on contact 1 and 3: - If voltage over 0V the battery is ok! Continue to step 4. 4. Verify contact between control box and battery. Maximum charge is reached after about 5 hours. When the batteries are fully charged, the charger switches automatically to maintenance charging. 4a) Remove the battery and wait for green LED to turn off. The lamps blink alternately (yellow/yellow/green) during charging. A blinking green lamp indicates that charging is complete. When operating time is noticeably shorter than normal, the batteries should probably be replaced. Discontinue charging and replace the batteries with 2006107 Extra battery box. 4b) Put back the battery and see if green LED start automatically. - If green LED starts, battery contact is ok! - If not, try to ensure that the battery´s contact plates are not defective or broken and try to bend them out carefully, then repeat step 4. off. - If still no contact, continue to step 5. 1 2 3 1 2 3 Prod. No. 2006107 Extra battery box 5. Check charging function 5a) Connect the charging cable to mains - If charging starts within 1 minute, charge and then continue to step 6. 4 5 - If charging doesn´t start, continue to step 5b. 5b) eries are fully charged, the charger switches 14 www.liko.com Measure output voltage on the control box 5 on contact 1 and 3. - If voltage is 3-4V charging is OK! Replace the battery, continue to step 6. - If voltage is 0V when the charging cable is connected to mains the control box needs to be replaced! Replace the control box. g. A blinking green lamp indicates that charging 6. Charge the battery until green LED is flashing, on the battery. mal, the batteries should probably be replaced. - Check that all function´s on the control box is ok! If not , Replace control box. Customers tra battery box.FAQ: - The liftarms up/down function or base width in/out function doesn´t work? a) Change position on actuator and base motor cables. b) Perform step 2 and see if fault is on output channel or motors. - The control panel function´s on controlbox is ok, but the hand control has no function? a) Check to ensure that battery contact plates in the hand control are not defective or broken. - There´s no charging function? a) Verify contact between control box and battery. Perform step 4. b) Check charging function. Perform step 5. 3EN902101-01 13 www.liko.com Doc. No. 3EN800804-01 14 14 19 20 22 23 24 29 30 31 32 33 34 20090022 20090023 20090089 20090026 20090027 20090028 20090034 20090035 20090036 20090037 20090038 20090039 38 18 20090020 20090043 16 20090019 37 15 20090018 20090042 14 20090016 36 13 20090015 20090041 12 20090014 35 11 20090013 20090040 4 10 20090004 3 Front Wheel 100 mm Front Wheel 50 mm Spring Magazine End Cover Armrest End Cover Handle/Arm Support Gear Rack set G7 / 77 Rear Fork Cover G7 / 77 Front Fork Cover G7 / 77 Rear Wheel 100 mm Front Wheel 75 mm Cable for charging US Cable for charging UK Cable for charging EU Hand Control 6-Button Attachment for Control Box Control Box G7-77 ES Roll Frame Attach. G7 / 77 Lift Strap G77 to S/N 7723629 Lift Strap G7/G8 Body/Handle set for Em.Low. Device G7 / 77 Emergency Lowering Device Golvo, grey Actuator G7 / 77 Armrest complete G7 / 77 Middle Beam G77 Middle Beam G7 POS. NAME NO. 20090003 SPARE PART NO. x x x x x x x x x x x x x x x x x x x x x x x x x x x x x x x x x x x x x x x x (x) x x x x x 7007 ES to S/N 7729721 7000 ES to S/N 7024205 x x x x x x x x x x x x 7000 ES fr. S/N 7024206 (Face lift) 2000010 2000009 2000009 x x x x x x x x x x x 7007 ES fr. S/N 7729722 (Face lift) x x x x x x x x x x x x 7000 ES Classic 2000010 2000050 x x x x x x x x x x x 7007 ES Classic x x x x x x x x x x x 7007 LowBase 2000051 2000061 x x x x 8008 LowBase 2000019 x x x x x 8008 LowBase Cable x x x x x 8000 2000039 2000014 x x x x x x 8000 Cable x x x x 8008 2000034 2000015 x x x x x 8008 Cable 2000035 x x x x x 8000 Classic 2000024 x x x x 8008 Classic 2000025 Golvo - Spare Parts data 5.0 www.liko.com w w w . liko. com Doc. No. 3EN800804-01 39 40 79 86 87 139 159 160 185 218 248 250 251 263 264 274 275 279 280 284 285 292 293 294 20090045 31190008 20190078 31190018 2006106 20390006 21090001 20090048 20090049 20090050 20090051 20090052 15 15 21090011 31590011 20090059 20090060 20090064 20090065 20490014 20490015 20090058 20090066 20090067 End Cover Armrest, grey End Cover Handle/Arm Support, grey Hook for Hand control Rear Wheel 75 mm , Std Front Wheel 75 mm Standard Base Motor Cover, grey Roll Frame Attachment Golvo, grey Plastic Housing, grey Motor for Base with Adjustment Golvo, grey Latch Universal SlingBar Extension Cable US Limit Switch G7 / 77 Reinforcement Plate Cable for Charging AU/NZ Base Motor Cover Lift Strap G77 ES /G88 Extension Cable Front Fork Cover Extra Battery Safety Latch SlingBar Standard 450 Plastic Housing Rear Wheel 125 mm Rear Wheel 75 mm POS. NAME NO. 20090044 SPARE PART NO. x x x x x x x x x x x x x x x x x x x x x x x x x x x x x 7007 ES to S/N 7729721 7000 ES to S/N 7024205 x x x x x x x x x x x x x x x x x 7000 ES fr. S/N 7024206 (Face lift) 2000010 2000009 2000009 x x x x x x x x x x x x x x x x x x 7007 ES fr. S/N 7729722 (Face lift) x x x x x x x x x x x x x x x x 7000 ES Classic 2000010 2000050 x x x x x x x x x x x x x x x x x 7007 ES Classic x x x x x x x x x x x x x x x x x 7007 LowBase 2000051 2000061 x x x x x x x x x x x 8008 LowBase 2000019 x x x x x x x x x x x x 8008 LowBase Cable x x x x x x x x x x x 8000 2000039 2000014 x x x x x x x x x x x x 8000 Cable x x x x x x x x x x x x 8008 2000034 2000015 x x x x x x x x x x x x x 8008 Cable 2000035 x x x x x x x x x x 8000 Classic 2000024 x x x x x x x x x x x 8008 Classic 2000025 Golvo - Spare Parts data 5.0 www.liko.com w w w. liko. com Doc. No. 3EN800804-01 311 323 324 330 333 336 336C Control Unit CBL by S/N, cable 348 349 350 351 352 353 354 397 398 404 411 411C Control Unit CBL, Golvo Cable 413 419 420 421 422 31590014 20090069 20090070 20090071 20490031 20490039 20490054 21090018 21090019 2006107 21090020 21090021 16 16 21090022 21090023 31590005 31590025 20090072 20090073 20090088 20490037 2006010 20090074 20090076 20090077 Locking device CBL20, Limit Switch PCBA Limit Switch Box Adapter Golvo (for Scale) Rear Wheel fork Control Unit CBL, Golvo Friction plates 2,8-3,4 mm Lift strap joint Q-link Hand control hanger Charge cable hook Clips with hook HBL20 Beltclip HBL20 Extra Battery Box Extension cable CBL20, US Extension cable CBL20 Control Unit CBL, by S/N Wireless hand control HBL20 Low base kit Golvo 7007/8008 Easy Strapper G77/G88 from S/N 7723630 Easy Strapper G7/G8 Latch, composite POS. NAME NO. SPARE PART NO. x x x x x x x x x x x x x 7007 ES to S/N 7729721 7000 ES to S/N 7024205 x x x x x x 7000 ES fr. S/N 7024206 (Face lift) 2000010 2000009 2000009 x x x x x x x 7007 ES fr. S/N 7729722 (Face lift) x x x x x x 7000 ES Classic 2000010 2000050 x x x x x x x 7007 ES Classic x x x x x x x 7007 LowBase 2000051 2000061 x x x x x x x x x x x x x x x x x x x x 8008 LowBase 2000019 x x x x x x x x x x x x x x x x x 8008 LowBase Cable x x x x x x x x x x x x x x x x x x x x 8000 2000039 2000014 x x x x x x x x x x x x x x x x x 8000 Cable x x x x x x x x x x x x x x x x x x x x 8008 2000034 2000015 x x x x x x x x x x x x x x x x x 8008 Cable 2000035 x x x x x x x x x x x x x x x x x x x 8000 Classic 2000024 x x x x x x x x x x x x x x x x x x x x 8008 Classic 2000025 Golvo - Spare Parts data 5.0 www.liko.com w w w. liko. com Doc. No. 3EN800804-01 423 425 485 486 487 490 492 496 511 512 514 515 516 20090078 21090028 20090080 20090081 20090082 20490052 20090085 20090087 20490057 20490060 2006001 17 17 2004304 2004305 Wheel Set 100/125 Wheel Set 50/75 Parking Hook for SlingBar Front Wheel Fork Locking Ring CBL Lift strap Cover Strip 7000/8000 Lift strap Cover Strip 7007/8008 SlingBar Assembly set Parking bracket Wheel Fork Fork locking attachment Grease SHC460 30g Actuator G8-88 POS. NAME NO. SPARE PART NO. x x x x x x x x x x x x 7007 ES to S/N 7729721 7000 ES to S/N 7024205 x x x x x x 7000 ES fr. S/N 7024206 (Face lift) 2000010 2000009 2000009 x x x x x x 7007 ES fr. S/N 7729722 (Face lift) x x x x x x 7000 ES Classic 2000010 2000050 x x x x x x 7007 ES Classic x x x x x x 7007 LowBase 2000051 2000061 x x x x x x x 8008 LowBase 2000019 x x x x x x x x 8008 LowBase Cable x x x x x x x x 8000 2000039 2000014 x x x x x x x x x 8000 Cable x x x x x x x 8008 2000034 2000015 x x x x x x x x 8008 Cable 2000035 x x x x x x x 8000 Classic 2000024 x x x x x x x 8008 Classic 2000025 Golvo - Spare Parts data 5.0 www.liko.com w w w. liko. com Spare Parts List 5.0 Spare Parts Golvo (G7=Golvo 7000, G77=Golvo 7007, G8=Golvo 8000, G88=Golvo 8008) PROD. NO. POS. NO. NAME UNIT Golvo LiftStrap 20090018 14 Lift Strap G7 / G8 pce Grey strap and grey plastic details 20090019 15 Lift Strap G77 up to S/N 7723629 pce 20090048 185 Lift Strap G77 (from S/N: 7723630) / G88 Grey strap and grey plastic details pce 20090069 323 Easy Strapper G7 / G8 Grey strap and grey plastic details set 20090070 324 Easy Strapper G77 from S/N 7723630 / G88 Grey strap and grey plastic details set Golvo Control Units 20090022 18 Control Box G7 / 77 ES pce 20090022US 18 Control Box G7 / 77 ES, US pce only for the US market 20490039 336 Control Unit CBL, by S/N Can only be ordered if S/N (serial number) can be provided to Liko Customer Service. Will be programmed at Liko before delivery. pce 2 weeks delivery time from Liko. Doc. No. 3EN800804-01 18 18 w w w .lik o .com www.liko.com Spare Parts List 5.0 Spare Parts Golvo (G7=Golvo 7000, G77=Golvo 7007, G8=Golvo 8000, G88=Golvo 8008) PROD. NO. 20490054 POS. NO. 336C NAME UNIT Control Unit CBL by S/N, Cable Can only be ordered if S/N (serial number) can be provided to Liko Customer Service. Will be programmed at Liko before delivery. pce 2 weeks delivery time from Liko. 20090073 411 Control Unit CBL, Golvo Before use; requires Software and, needs to be programmed with Liko Service System, Prod. No. 21090024 pce 20090088 411C Control Unit CBL Golvo, Cable Before use; requires Software and, needs to be programmed with Liko Service System, Prod. No. 21090024 pce Golvo Spare Parts 20090003 3 Middle Beam G7 up to S/N 7024205 pce 20090004 4 Middle Beam G77 up to S/N 7729721 pce 20090013 10 Armrest complete G7 / 77 up to S/N 7024205 / 7729721 set 20090014 11 Actuator G7 / 77 For Golvo 7000/7007 with S/N 700001-702297 / 770001 - 771050 the mast must be modified according to the Service Manual pce 20090015 12 Emergency Lowering Golvo, grey pce 20090016 13 Body/Handle set for Emergency Lowering Device pce Doc. No. 3EN800804-01 19 19 www. liko . com www.liko.com Spare Parts List 5.0 Spare Parts Golvo (G7=Golvo 7000, G77=Golvo 7007, G8=Golvo 8000, G88=Golvo 8008) PROD. NO. POS. NO. NAME UNIT 20090020 16 Roll Frame Attachment G7 / 77 up to S/N 7024205 / 7729721 pce 20090023 19 Attachment for Control Box pce 20090089 20 Hand control 6-Button pce 20090026 22 Cable for charging EU pce 20090027 23 Cable for charging UK pce 20090028 24 Cable for charging US pce 20090034 29 Front Wheel 75 mm up to S/N 7024205 / 7729721 pce 20090035 30 Rear Wheel 100 mm up to S/N 7024205 / 7729721 pce 20090036 31 Front Fork Cover G7 / 77 up to S/N 7024205 / 7729721 pair 20090037 32 Rear Fork Cover G7 / 77 up to S/N 7024205 / 7729721 pair 20090038 33 Gear Rack set set 20090039 34 End Cover Handle/Arm Support up to S/N 7024205 / 7729721 set Doc. No. 3EN800804-01 20 20 www.liko.com www.liko.com Spare Parts List 5.0 Spare Parts Golvo (G7=Golvo 7000, G77=Golvo 7007, G8=Golvo 8000, G88=Golvo 8008) PROD. NO. 20090040 POS. NO. 35 NAME UNIT End Cover Armrest up to S/N 7024205 / 7729721 pair x2 x4 20090041 36 Spring Magazine pce 20090042 37 Front Wheel 50 mm up to S/N 7024205 / 7729721 pce 20090043 38 Front Wheel 100 mm up to S/N 7024205 / 7729721 pce 20090044 39 Rear Wheel 75 mm up to S/N 7024205 / 7729721 pce 20090045 40 Rear Wheel 125 mm up to S/N 7024205 / 7729721 pce 31190008 79 Plastic Housing up to S/N 7024205 / 7729721 pce 20190078 86 SlingBar Standard 450 up to S/N 7024205 / 7729721 pce 31190018 87 Latch up to S/N 7024205 / 7729721 pair 2006106 139 Extra Battery pce 20390006 159 Front Fork Cover LL, Vi, Golvo from S/N 7024206 / 7729722 pair 21090001 160 Extension Cable pce Doc. No. 3EN800804-01 21 21 w w w .lik o .com www.liko.com Spare Parts List 5.0 Spare Parts Golvo (G7=Golvo 7000, G77=Golvo 7007, G8=Golvo 8000, G88=Golvo 8008) PROD. NO. POS. NO. NAME UNIT 20090049 218 Base Motor Cover , black fits S/N: G7 7021494 - 7024205 G77 7722428 - 7729721 pce 20090050 248 Cable for Charging AU/NZ pce 20090051 250 Reinforcement Plate Golvo from S/N: 7022914 / 7725944 pce 20090052 251 Limit Switch G7 / 77 pce 21090011 263 Extension Cable US pce 31590011 264 Latch Universal SlingBar pair 20090059 274 Motor Base Width Adjustment Golvo, grey replaces 20090005 and 20090046 20090060 275 Plastic Housing grey from S/N 7024206 / 7729722 pce 20090064 279 Roll Frame Attachment Golvo, grey from S/N 7024206 / 7729722 pce 20090065 280 Base Motor Cover grey from S/N 7024206 / 7729722 set 20490014 284 Front Wheel 75 mm Standard from S/N 7024206 / 7729722 pce 20490015 285 Rear Wheel 75 mm Standard from S/N 7024206 / 7729722 pce Doc. No. 3EN800804-01 22 22 w w w .lik o. com www.liko.com Spare Parts List 5.0 Spare Parts Golvo (G7=Golvo 7000, G77=Golvo 7007, G8=Golvo 8000, G88=Golvo 8008) PROD. NO. POS. NO. NAME UNIT 20090058 292 Hook for Hand control 2,4,6 pce 20090066 293 End Cover Handle/Arm Support grey, 4 pce from S/N 7024206 / 7729722 set 20090067 294 End Cover Armrest, grey from S/N 7024206 / 7729722 set 31590014 311 Latch, composite Fits Universal SlingBar from S/N 1299511 pair 20090071 330 Low base kit Golvo 7007/8008 set 20490031 333 Wireless hand control HBL20 set 21090018 348 Extension cable CBL pce 21090019 349 Extension cable CBL, US pce 2006107 350 Extra Battery Box pce 21090020 351 Beltclip HBL20 pair 21090021 352 Clips with hook HBL20 pair 21090022 353 Charge cable hook , 10 pce set 21090023 354 Hand control hanger, 10 pce set 31590005 397 Q-link pce 31590025 398 Lift strap joint pce Doc. No. 3EN800804-01 23 23 www.lik o.com www.liko.com Spare Parts List 5.0 Spare Parts Golvo (G7=Golvo 7000, G77=Golvo 7007, G8=Golvo 8000, G88=Golvo 8008) PROD. NO. POS. NO. NAME UNIT 20090072 404 Friction plates 2.8-3.4 mm 20 pce of each model (2.8, 3.0, 3.2, 3.4 mm) set 20490037 413 Rear Wheel fork Golvo 7000, up to S/N 7024205 Golvo 7007, up to S/N 7729721 pair 2006010 419 Adapter Golvo (for Scale) set 20090074 420 Limit switch box set 20090076 421 Limit Switch PCBA set 20090077 422 Locking device CBL20, 10 pce set 20090078 423 Actuator G8-88 pce 21090028 425 Grease SHC460 30g pce 20090080 485 Fork locking attachment, 4 pair set 20090081 486 Wheel Fork pair 20090082 487 Parking bracket pce Doc. No. 3EN800804-01 24 24 w w w .lik o .com www.liko.com Spare Parts List 5.0 Spare Parts Golvo (G7=Golvo 7000, G77=Golvo 7007, G8=Golvo 8000, G88=Golvo 8008) PROD. NO. POS. NO. NAME UNIT 20490052 490 SlingBar Assembly set set 20090085 492 Lift strap Cover Strip, 7007/8008 pce 20090087 496 Lift strap Cover Strip, 7000/8000 pce 20490057 511 Locking Ring CBL, 10 pce set 20490060 512 Front Wheel Fork pair 2006001 514 Parking Hook for SlingBar set Incl. mounting screws. 2004304 515 Wheel Set 50/75 (lower base clearance) Fits: Golvo 7000 to S/N 7024205 Golvo 7007 to S/N 7729721 2004305 516 Wheel Set 100/125 (higher base clearance) Fits: Golvo 7000 to S/N 7024205 Golvo 7007 to S/N 7729721 Doc. No. 3EN800804-01 25 25 w w w . liko. com www.liko.com 5.12 Emergency Lowering Golvo, grey Nödsänkning Golvo, grå Contains: Locking pin 3x48 Friction profile Body emergency lowering Plastic Housing, grey Cover spring magazine Strap shaft emergency low Axelstop Left emerg. Axelstop right emerg. Emergency lowering Handle Screw K6S M5x12 Screw WN 1412,3x20 Tube 10x12 L=60 Alu. Emer Nut M6M M5 Pin 6x30 emerg. Spring magazine Torsion spring Right Torsion spring left Assembly Instruction Monteringsanvisning Qty: 1 1 1 1 (was black before) 1 1 1 1 1 1 2 1 1 2 1 1 1 Prod. No. 20090015 3SE640253-02 2010-05-03 Tools required: 13 mm Fits: Golvo 7000/7007 (all models) Golvo 8000/8008 (all models) 1. Pull the strap all the way out. 2. Hold the spring loaded wheel 3. Remove the pin. Do not let go and release the strap by removing of the spring loaded wheel, since the pin. the tension will release. © Copyright Liko AB 26 4. Use the pin to lock the axle where the strap was mounted. www.liko.com www.liko.com 5.12 Emergency Lowering Golvo, grey Nödsänkning Golvo, grå Assembly Instruction Monteringsanvisning Prod. No. 20090015 5. Push the emergency lowering handle down and pull the strap away. 6. Pull the rest of the strap out and remove the plastic housing. 8. Mount the strap through the slot 9. Push the plastic housing on to in the axle and the same way back. the strap joint. Note! The axle has two different sides. Place the pin as shown to lock the strap. Do not let go of the spring loaded wheel, since the tension will release. 7. Mount the new strap through the plastic housing with the red mark towards the plastic housing and then as shown above. 10. Roll the strap up until the red mark reaches the plastic housing. NOTE - Make sure the spare part is mounted according to the assembly instruction. - Check all functions related to the changed spare part. - Repairs and maintenance may only be performed by personnel authorized by Hill-Rom/Liko and using original Liko spare parts. © Copyright Liko AB 27 www.liko.com www.liko.com 5.13 Body/Handle set for Emergency Lowering Device Stomme handtag Contains: Body emergency lowering Axelstop Left emerg. Axelstop right emerg. Emergency lowering Handle Tube 10x12 L=60 Alu. Emer Pin 6x30 emerg. Friction profile Torsion spring Right Torsion spring left Assembly Instruction Monteringsanvisning Qty: 1 1 1 1 1 2 1 1 1 Prod. No. 20090016 3SE630285-02 2010-05-03 Tools required: 13 mm Fits: Golvo 7000/7007 (all models) Golvo 8000/8008 (all models) 1. Pull the strap all the way out. 2. Hold the spring loaded wheel 3. Remove the pin. Do not let go and release the strap by removing of the spring loaded wheel, since the pin. the tension will release. © Copyright Liko AB 28 4. Use the pin to lock the axle where the strap was mounted. www.liko.com www.liko.com 5.13 Body/Handle set for Emergency Lowering Device Stomme handtag Assembly Instruction Monteringsanvisning Prod. No. 20090016 5. Push the emergency lowering handle down and pull the strap away. 6. Pull the rest of the strap out and remove the plastic housing. 8. Mount the strap through the slot 9. Push the plastic housing on to in the axle and the same way back. the strap joint. Note! The axle has two different sides. Place the pin as shown to lock the strap. Do not let go of the spring loaded wheel, since the tension will release. 7. Mount the new strap through the plastic housing with the red mark towards the plastic housing and then as shown above. 10. Roll the strap up until the red mark reaches the plastic housing. NOTE - Make sure the spare part is mounted according to the assembly instruction. - Check all functions related to the changed spare part. - Repairs and maintenance may only be performed by personnel authorized by Hill-Rom/Liko and using original Liko spare parts. © Copyright Liko AB 29 www.liko.com www.liko.com