Download Samsung SGH-ZV60 service manual
Transcript
UMTS TELEPHONE SGH-ZV60 UMTS TELEPHONE CONTENTS 1. Safety Precautions 2. Specification 3. Operation Instruction and Installation 4. Array course control 5. Exploded View/Disassembly and Assembly Instructions 6. MAIN Electrical Parts List 7. Block Diagrams 8. PCB Diagrams 9. Flow Chart of Troubleshooting 10. Reference data GSPN (Global Service Partner Network) Country North America Latin America CIS Europe China Asia Mideast & Africa Web Site service.samsungportal.com latin.samsungportal.com cis.samsungportal.com europe.samsungportal.com china.samsungportal.com asia.samsungportal.com mea.samsungportal.com This Service Manual is a property of Samsung Electronics Co.,Ltd. Any unauthorized use of Manual can be punished under applicable International and/or domestic law. ⓒ Samsung Electronics Co.,Ltd. 2007. 06. Rev.1.0 1. Safety Precautions 1-1. Repair Precaution ● Repair in Shield Box, during detailed tuning. Take specially care of tuning or test, because specipicity of cellular phone is sensitive for surrounding interference(RF noise). ● Be careful to use a kind of magnetic object or tool, because performance of parts is damaged by the influence of magnetic force. ● Surely use a standard screwdriver when you disassemble this product, otherwise screw will be worn away. ● Use a thicken twisted wire when you measure level. A thicken twisted wire has low resistance, therefore error of measurement is few. ● Repair after separate Test Pack and Set because for short danger (for example an overcurrent and furious flames of parts etc) when you repair board in condition of connecting Test Pack and tuning on. ● Take specially care of soldering, because Land of PCB is small and weak in heat. ● Surely tune on/off while using AC power plug, because a repair of battery charger is dangerous when tuning ON/OFF PBA and Connector after disassembling charger. ● Don't use as you pleases after change other material than replacement registered on SEC System. Otherwise engineer in charge isn't charged with problem that you don't keep this rules. 1-1 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Safety Precautions 1-2. ESD(Electrostatically Sensitive Devices) Precaution Several semiconductor may be damaged easily by static electricity. Such parts are called by ESD (Electrostatically Sensitive Devices), for example IC,BGA chip etc. Read Precaution below. You can prevent from ESD damage by static electricity. ● Remove static electricity remained your body before you touch semiconductor or parts with semiconductor. There are ways that you touch an earthed place or wear static electricity prevention string on wrist. ● Use earthed soldering steel when you connect or disconnect ESD. ● Use soldering removing tool to break static electricity. , otherwise ESD will be damaged by static electricity. ● Don't unpack until you set up ESD on product. Because most of ESD are packed by box and aluminum plate to have conductive power,they are prevented from static electricity. ● You must maintain electric contact between ESD and place due to be set up until ESD is connected completely to the proper place or a circuit board. 1-2 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization 2. Specification 2-1. GSM General Specification EG SM 9 00 DCS1800 PCS1900 W-CDMA Fr eq. Band[MHz] Uplin k/Down link 8 80~915 9 25~960 17 10~178 5 18 05~188 0 18 50~191 0 19 30~199 0 192 0~1980 211 0~2170 ARF CN ra nge 0~124 & 97 5~1023 5 12~885 5 12~810 UL: 96 12~988 8 DL: 105 62~108 38 T x/Rx spacing 45MHz 95MHz 80MHz 1 90MHz Mo d. Bit r ate/ Bit Period 270 .833kb ps 3 .692u s 270 .833kb ps 3 .692u s 270 .833kb ps 3 .692u s 3.8 4Mcps Ti me Slo t Pe rio d/Fr am e Per iod 5 76.9u s 4. 615ms 5 76.9u s 4. 615ms 5 76.9u s 4. 615ms Fr ame len gth : 10ms Modula tion 0 .3G M SK 0 .3G MSK 0 .3G M SK Q PS K HQPSK MS Power 33d Bm~5dBm 30d Bm~0dBm 30d Bm~0dBm 24 dBm~- 50dBm Powe r Class 4 (max +33dBm) 1 (max +30dBm) 1 (max +30dBm) 3 (max +24dBm) Se nsitivity -10 2dBm -10 0dBm -10 0dBm -1 06.7d Bm TDMA Mu x 8 8 8 Cell Radiu s 35Km 2Km 2Km 2-1 2Km Speclflcation 2-2. GSM Tx Power Class TX Power control level GSM900 TX Power control level DCS1800 TX Power control level PCS1800 5 33±2 dBm 0 30±3 dBm 0 30±3 dBm 6 31±2 dBm 1 28±3 dBm 1 28±3 dBm 7 29±2 dBm 2 26±3 dBm 2 26±3 dBm 8 27±2 dBm 3 24±3 dBm 3 24±3 dBm 9 25±2 dBm 4 22±3 dBm 4 22±3 dBm 10 23±2 dBm 5 20±3 dBm 5 20±3 dBm 11 21±2 dBm 6 18±3 dBm 6 18±3 dBm 12 19±2 dBm 7 16±3 dBm 7 16±3 dBm 13 17±2 dBm 8 14±3 dBm 8 14±3 dBm 14 15±2 dBm 9 12±4 dBm 9 12±4 dBm 15 13±2 dBm 10 10±4 dBm 10 10±4 dBm 16 11±3 dBm 11 8±4dBm 11 8±4dBm 17 9±3dBm 12 6±4 dBm 12 6±4 dBm 18 7±3 dBm 13 4±4 dBm 13 4±4 dBm 19 5±3 dBm 14 2±5 dBm 14 2±5 dBm 15 0±5 dBm 15 0±5 dBm 2-2 3. Operation Instruction and Installation Main Function ― Built-in Digital Cameras( CMOS 2 Mega , CMOS VGA ) ― 1.9" Main LCD ( 260K TFT ), 1.07" Sub LCD (CSTN) ― Video Telephony / Streaming ― Bluetooth V2.0 Wireless Technology ― USB 2.0 ― MP3 player ― Folder Upper Music Key(Touch key) ― Downloadable Game via JAVA ― Sending Photo & Video by MMS or E-Mail ― Supporting 72 Polyphonic Ring Tone ― WAP 2.0 Browser ( Including xHTML/WCSS MP, w/HTTP ) ― External Memory Card Socket( T-flash ) ― GSM 900MHz & DCS1800MHz & 1900MHz & WCDMA 2100MHz ― GPRS Class 12 3-1 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Operation Instruction and Installation 3-2 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization 4. Array course control 4-1. Software Adjustments 1 2 GH80-03308A GH39-00397A 4 3 GH39-00478A GH44-01361A 5 6 GH39-00444A 1. 2. 3. 4. 5. 6. JIG: Download, Trace, Calibration, etc RF test cable: RF test Test cable: JIG to phone TA (Travel Adaptor) Data Link Cable : USB cable Serial cable: PC to JIG 4-1 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Array course control 4-2. Software Downloading 4-2-1. Downloading Binary Files • Four binary files for downloading ZV60. – amss_compressed.bin : Modem binary for communication function & Mocha binary for user interface and various application – Rsrc_ZV60_○○○.rc1: Files need for each application – Rsrc2_ZV60(Low).rc2 : Power on/off animation – FactoryFS_ZV60_○○○.ffs : Default file system to be put into in initial production 4-2-2. Pre-requsite for Downloading • Downloader Program( FastMultiLoader V5.00.exe ) • SGH-ZV60 Mobile Phone • USB Data Link Cable • Binary files 4-2 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Array course control 4-2-3. S/W Downloader Program 1. Boot the ZV60 by pressing ‘Power ON key’ + ‘Number 9 key’ at the same timeIf you do properly, you can see the following message on LCD “DOWNLOAD” or RED SCREEN 2. Load the binary download program by executing the “FastMultiLoader V5.00.exe”. And then Check the 6245. 3. Select the check box what you want to download. 4-3 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Array course control 4. Select the binary file what you want to download 4-4 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Array course control 5. Now press the button ‘Port Search’ 6. Now press the button ‘Download’ 7. When downloading is complete, UE reboot automatically. - If there is difference in FactoryFs.bin, UE will format file system automatically. 4-5 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Array course control 4-6 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization 5. Exploded View/Disassembly&Assembly Instructions 5-1. Cellular Phone Exploded View QRF03 QWD01 QFR01 QME03 QFU01 QCR12 QCA04 QKP01 QCW01 QME01 QVK02 QMI03 QMP01 QCA02 QMI01 QVK01 QLC01 QCA01 QSP01 QAN05 QMO01 QCR12 QAN02 QCK01 QHI01 QRE01 QFL01 QVO01 QSD01 QCW02 QCR12 QCR12 QSC02 QSC01 QBA01 QMW01 QBA00 5-2 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Exploded View/Disassembly&Assembly Instructions 5-2. Cellular Phone Parts list Design LOC Description SEC CODE QAN02 INTENNA-SGH ZV60 GH42-01187A QAN05 ASSY MEC-INTENNA CONTACT GH75-08168A QBA00 PMO-COVER BATTERY GH72-37218A QBA01 INNER BATTERY PACK-960MAH,BLK, GH43-02720A QCA01 UNIT-CAMERA MODULE GH59-04089A QCA02 UNIT-VGA CAMERA GH59-04140A QCA04 ICT-DECO MEGA CAMERA GH70-01992A QCK01 PMO-CAMERA KEY GH72-37214A QCR12 SCREW-MACHINE 6001-001530 QCR12 SCREW-MACHINE 6001-001530 QCR12 SCREW-MACHINE 6001-001530 QCR12 SCREW-MACHINE 6001-001530 QCW01 PCT-COVER WINDOW MEGA CAM GH72-37221A QCW02 PCT-COVER WINDOW VGA CAM GH72-37222A QFL01 ASSY CASE-LOWER FOLDER GH98-03768A QFR01 ASSY CASE-FRONT GH98-03767A QFU01 ASSY CASE-UPPER FOLDER GH98-03769A QHI01 ASSY MEC-HINGE GH75-04948A QKP01 ASSY KEYPAD-(VOD/BLK) GH98-03771A QLC01 ELA ETC-SGH ZV60 LCD MODULE GH96-02453A QME01 DOME SHEET-METAL DOME GH59-04109A QME03 KEY FPCB-SGHZV60 TOUCH KEY GH59-04133A QMI01 MICROPHONE-ASSY GH30-00394A QMI03 AS-SGHZV60 MIC RUBBER GH81-06647A QMO01 MOTOR DC-SGH ZV60 GH31-00313A QMP01 PBA MAIN-SGH ZV60 GH92-03460A QMW01 ASSY COVER-MAIN WINDOW GH98-04609A QRE01 ASSY CASE-REAR GH98-03770A QRF03 PMO-COVER EAR GH72-37217A QSC01 RMO-SCREW CAP L GH73-09420A QSC02 RMO-SCREW CAP R GH73-09421A QSD01 PMO-COVER SD GH72-37216A QSP01 SPEAKER 3001-002114 QVK01 KEY FPCB-VOLUME KEY ASSY GH59-04204A QVK02 KEY FPCB-CAM KEY FPCB GH59-04203A QVO01 PMO-VOLUME KEY GH72-37213A QWD01 PCT-COVER SUB WINDOW GH72-37224A 5-2 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Exploded View/Disassembly&Assembly Instructions Description SEC CODE CBF INTERFACE-DATA LINK CABLE GH39-00444A ADAPTOR-SGHE690,BLK,EU,A_TYPE GH44-01361A EARPHONE-EARPHONE,20P,B-TYPE GH59-03883A LABEL(R)-WATER SOAK GH68-09361A MPR-INSU TAPE LED GH74-31775A MPR-VINYL BOHO SUB WINDOW GH74-31128A MPR-REMOVE TAPE LCD GH74-13804A MPR-TAPE GH74-27509A MPR-INSU TAPE SUB LCD GH74-27510A MPR-INSU TAPE GH74-27511A MPR-INSU TAPE GH74-27512A MPR-TAPE DECO MEGA CAM GH74-30162A MPR-TAPE WINDOW MEGA CAM GH74-30163A MPR-VINYL BOHO SUB WINDOW GH74-31128A MPR-TAPE MAIN FPCB INSULATION GH74-24736A MPR-TAPE FPCB FRONT GH74-31774A ICT BRACKET-MEGA CAMERA GH70-02533A TAPE GASK GH74-32594A VINYL-BOHO REAR GH74-33383A S/W CD-PC STUDIO GH46-00424A MANUAL USERS-VODA SPANISH GH68-14787A MANUAL USERS-VODA QSG SPANISH GH68-14916A BAG PE 6902-000634 LABEL(R)-MAIN(VODA) GH68-14768A BOX-UNIT(VODA) GH69-05393A CUSHION-CASE(VODA) GH69-05394A 5-3 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Exploded View/Disassembly&Assembly Instructions 5-3. Disassembly and Assembly Instructions 5-3-1. Disassembly 1 2 1.Unscrew the 4 points. 2.Separate the REAR from the FRONT ass'y using assembly stick. 1.Disjoin the connectors from the PBA. ※ Caution ※ Caution 1) Be care of scratch and molding damage. 1) Be care of scratch and molding damage. 1) Be care of damage to the FPCBs. 3 4 1. Take out the PBA, KEYPAD. 1. Push the hinge with a thin stick to separate the UPPER 2. Detach the DUST PROTECTION TAPE. from the LOWER. ※ Caution ※ Caution 1) Be care of damage to the FPCBs. 1) Be care of scratch and molding damage. 2) Be care of scratch and molding damage. 5-4 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Exploded View/Disassembly&Assembly Instructions 5 6 1.Detach the two SCREW CAPs. 2.Put the HINGE DUMMY out. 1.Disassemble the UPPER by using a assembly stick. 3.Unscrew 2 points. ※ Caution ※ Caution 1) Be care of scratch and molding damage. 1) Be care of scratch and molding damage. 7 8 1. Separate a motor/speaker/Mega,Vga camera from the LOWER using a tweezer. 2. Separate the LCD module from the LOWER. 1.Take the LCD out. ※ Caution ※ Caution 1) Be care of scratch and molding damage. 1) Be care of scratch and molding damage. 2) Be care of damage to motor/speaker wires. 2) Be care of damage to LCD FPCB.. 5-5 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Exploded View/Disassembly&Assembly Instructions 5-3-2. Assembly 1 2 1.Solder motor/speaker to the pad of LCD 1.Attach MEGA/VGA Camera module to the LCD. module and Bonding. ※ Caution ※ Caution 1) Be care of damage to the LCD module 1) Be care of damage to the LCD module 3 1.Attach one insulation tape to Camera connector. ※ Caution ※ Caution 1) Be care of scratch and molding damage. 1) Be care of scratch and molding damage. 5-6 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Exploded View/Disassembly&Assembly Instructions 4 5 1.Assemble the LCD into the lower. 1.Assemble the MOTOR/SPEAKER/MEGA,VGA CAMERA. ※ Caution ※ Caution 1) Be care of damage to F-PCB of LCD module. 1) Be care of scratch. 6 7 1.Assemble the MP3 KEY PCB CONNECTOR AND 1.Attach the MAIN/VGA CAMERA WINDOW. 2.Attach one insulation tape to MP3 connector ※ Caution ※ Caution 1) Be care of scratch and molding damage. 1) Be care of damage to the camera F-PCB. 5-7 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Exploded View/Disassembly&Assembly Instructions 8 9 1.Assemble the UPPER Screw two points. 1.Attach two SCREW CAPs. ※ Caution ※ Caution 1) Be care of scratch and molding damage. 10 1) Be care of scratch and molding damage. 11 1.Assemble the folder and the front by fitting hinge dummy in the front. 2.Push the hinge. 1.Attach the DUST PROTECTION TAPE. 2.Put the KEYPAD on the front ass'y. ※ Caution ※ Caution 1) Be care of scratch. 1) Be care of scratch and molding damage. 5-8 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Exploded View/Disassembly&Assembly Instructions 12 13 1.Put the PBA on the front ass'y. 2.Join the LCD connector to the PBA. 1.Place the VOLUME KEY/CAMERA KEY to both side of the assembly. ※ Caution 1) ※ Caution Be care of damage to the 1) Be care of scratch and molding damage. SIDE KEY/CAMERA F-PCBs. 14 1.Assemble the rear case to the assembly. 2.Screw down 4 points in the red circle. ※ Caution 1) Be care of scratch and molding damage. 5-9 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Exploded View/Disassembly&Assembly Instructions 5-10 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization 6. MAIN Electrical Parts List Design LOC Description SEC Code STATUS ANT100 ANT101 ANT102 BAT400 BTC600 C100 C103 C104 C105 C106 C107 C108 C109 C110 C111 C113 C115 C118 C119 C120 C121 C122 C123 C124 C126 C127 C129 C130 C131 C132 C133 C134 C135 C137 C138 C140 C141 C142 C143 C144 C145 C146 C148 C149 C151 C152 C156 C157 C162 C163 C164 C165 C166 NPR-ANTENNA CONTACT NPR-ANTENNA CONTACT ANTENNA-CHIP BATTERY-LI(2ND) HEADER-BATTERY C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP GH71-06379A GH71-06379A 4202-001299 4302-001180 3711-006137 2203-006556 2203-002668 2203-005659 2203-005659 2203-005659 2203-005659 2203-005727 2203-000696 2203-005382 2203-001437 2203-006423 2203-005725 2203-005725 2203-006423 2203-006423 2203-006379 2203-006423 2203-005682 2203-006423 2203-006423 2203-005725 2203-005444 2203-002677 2203-000438 2203-005682 2203-005682 2203-005682 2203-002968 2203-006556 2203-005393 2203-005444 2203-006423 2203-006423 2203-006423 2203-006423 2203-000812 2203-005056 2203-006194 2203-005725 2203-005725 2203-000233 2203-005736 2203-006305 2203-000854 2203-006648 2203-006423 2203-006562 2203-006872 SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA 6-1 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Main Electrical Parts List Design LOC Description SEC Code STATUS C167 C168 C169 C170 C171 C172 C173 C174 C175 C178 C179 C200 C201 C202 C203 C204 C205 C208 C209 C210 C211 C212 C213 C214 C215 C216 C217 C218 C219 C302 C304 C305 C306 C307 C308 C309 C311 C312 C313 C314 C315 C316 C317 C318 C319 C320 C321 C322 C324 C325 C326 C327 C328 C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP 2203-006562 2203-006872 2203-005736 2203-000233 2203-000330 2203-000233 2203-000386 2203-006842 2203-006120 2203-006562 2203-006423 2203-006194 2203-006194 2203-005736 2203-000233 2203-000278 2203-005052 2203-005725 2203-006194 2203-005736 2203-006423 2203-000254 2203-005806 2203-005482 2203-005806 2203-005682 2203-006194 2203-006194 2203-000696 2203-000489 2203-005480 2203-006423 2203-006423 2203-006423 2203-006979 2203-006979 2203-006423 2203-006423 2203-006979 2203-006979 2203-006423 2203-000233 2203-006423 2203-000812 2203-000254 2203-006194 2203-006194 2203-006194 2203-006194 2203-006194 2203-000438 2203-000438 2203-006562 SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SNA SA SNA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA 6-2 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Main Electrical Parts List Design LOC Description SEC Code STATUS C329 C330 C332 C333 C334 C335 C336 C337 C338 C339 C340 C341 C342 C343 C344 C345 C346 C347 C348 C349 C350 C352 C353 C354 C355 C400 C401 C402 C403 C404 C405 C406 C407 C408 C409 C410 C411 C412 C413 C414 C415 C416 C417 C418 C419 C420 C421 C422 C423 C424 C425 C426 C427 C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP 2203-000438 2203-000438 2203-006194 2203-006423 2203-000438 2203-006194 2203-006194 2203-006194 2203-006194 2203-006423 2203-006423 2203-006423 2203-006194 2203-006423 2203-006194 2203-006423 2203-006194 2203-006423 2203-006423 2203-006423 2203-006423 2203-006423 2203-005482 2203-000995 2203-005740 2203-006824 2203-006824 2203-006562 2203-006423 2203-005736 2203-005736 2203-000386 2203-000386 2203-006423 2203-006305 2203-006562 2203-006305 2203-006562 2203-006305 2203-006838 2203-006305 2203-006838 2203-006838 2203-006838 2203-006824 2203-006305 2203-006824 2203-005682 2203-006423 2203-006562 2203-006824 2203-006681 2203-006824 SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA 6-3 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Main Electrical Parts List Design LOC Description SEC Code STATUS C428 C429 C430 C431 C434 C435 C438 C439 C441 C442 C443 C444 C445 C446 C447 C448 C449 C450 C451 C452 C500 C501 C504 C506 C507 C508 C509 C511 C512 C513 C514 C515 C516 C517 C519 C520 C521 C522 C523 C524 C528 C530 C600 C601 C603 C607 C608 C700 C704 C705 C706 C800 CD400 C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP C-CER,CHIP CONNECTOR-CARD EDGE 2203-006681 2203-006562 2203-000812 2203-005682 2203-006824 2203-006824 2203-006048 2203-006048 2203-006048 2203-006562 2203-006562 2203-006562 2203-005682 2203-000812 2203-000812 2203-000812 2203-000812 2203-000812 2203-006824 2203-006824 2203-000278 2203-000812 2203-006562 2203-005482 2203-000278 2203-006305 2203-005482 2203-005482 2203-006048 2203-000254 2203-006260 2203-000254 2203-006260 2203-006562 2203-006648 2203-006257 2203-006305 2203-005682 2203-000278 2203-006648 2203-000812 2203-002709 2203-000425 2203-000425 2203-005682 2203-006562 2203-006562 2203-006562 2203-000386 2203-006562 2203-006562 2203-006423 3709-001392 SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA 6-4 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Main Electrical Parts List Design LOC Description SEC Code STATUS CPL200 D400 D401 D402 D500 D501 D600 D601 D602 D603 DUF200 F100 F101 F102 F103 F104 F200 F300 F700 F701 F702 F703 HDC700 IFC600 L100 L103 L104 L105 L106 L107 L108 L109 L110 L111 L112 L113 L114 L116 L118 L126 L200 L201 L205 L206 L207 L300 L400 L401 L602 L603 L604 L605 L606 COUPLER-DIRECTION DIODE-ARRAY DIODE-TVS DIODE-TVS DIODE-TVS DIODE-TVS DIODE-TVS DIODE-ZENER DIODE-TVS DIODE-ZENER DUPLEXER-SAW DUPLEXER-FEM FILTER-SAW FILTER-SAW BEAD-SMD FILTER-LC FILTER-SAW FILTER-EMI SMD FILTER-EMI/ESD FILTER-EMI/ESD FILTER-EMI/ESD FILTER-EMI/ESD HEADER-BOARD TO BOARD SOCKET-INTERFACE INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD BEAD-SMD INDUCTOR-SMD INDUCTOR-SMD INDUCTOR-SMD BEAD-SMD BEAD-SMD BEAD-SMD BEAD-SMD BEAD-SMD 4709-001399 0407-001002 0406-001215 0406-001215 0406-001254 0406-001254 0406-001208 0403-001547 0406-001208 0403-001427 2910-000010 2911-000079 2904-001623 2904-001703 3301-001534 2909-001285 2904-001658 2901-001283 2901-001418 2901-001418 2901-001418 2901-001418 3711-005367 3710-002442 2703-002170 2703-002955 2703-002793 2703-002793 2703-002793 2703-002858 2703-002798 2703-002901 2703-002858 2703-002798 2703-002900 2703-002955 2703-002798 2703-002900 2703-001726 2703-002596 2703-002170 2703-002842 2703-002281 2703-002798 3301-001756 2703-002858 2703-002840 2703-002840 3301-001885 3301-001885 3301-001885 3301-001756 3301-001756 SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SNA SNA SA SNA SA SA SNA SA SA SA SA SA SA SNA SA SA SA SA SA SA SA SA SA 6-5 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Main Electrical Parts List Design LOC Description SEC Code STATUS L800 LED800 LED801 MOD100 OSC100 OSC400 PAM100 PAM200 R100 R101 R102 R103 R104 R105 R107 R108 R109 R110 R112 R113 R114 R116 R118 R119 R120 R121 R122 R123 R130 R131 R132 R133 R200 R201 R202 R203 R204 R205 R206 R300 R301 R302 R303 R305 R307 R308 R310 R311 R312 R313 R314 R315 R316 BEAD-SMD LED LED IC-TRANSCEIVER CRYSTAL-SMD CRYSTAL-SMD IC-POWER AMP IC-POWER AMP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP 3301-001534 0601-002268 0601-002268 1205-002942 2801-004515 2801-004339 1201-002534 1201-002305 2007-008542 2007-008542 2007-008542 2007-008542 2007-008542 2007-001285 2007-007309 2007-008419 2007-008419 2007-008419 2007-001119 2007-001285 2007-008531 2007-001298 2007-001305 2007-001305 2007-000174 2007-008588 2007-001305 2007-001305 2007-008542 2007-007489 2007-009084 2007-008542 2007-001298 2007-003022 2007-001303 2007-001303 2007-000138 2007-001298 2007-000162 2007-008516 2007-000148 2007-000148 2007-008055 2007-000171 2007-000137 2007-008542 2007-007142 2007-000171 2007-007318 2007-007314 2007-007135 2007-007741 2007-007317 SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA 6-6 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Main Electrical Parts List Design LOC Description SEC Code STATUS R317 R318 R320 R321 R322 R323 R324 R325 R326 R327 R400 R401 R402 R403 R404 R405 R406 R408 R409 R410 R411 R412 R413 R414 R415 R418 R419 R420 R421 R422 R424 R501 R502 R503 R504 R506 R507 R508 R509 R600 R601 R602 R603 R604 R605 R703 R704 R705 R706 R707 R708 R709 R710 R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP R-CHIP 2007-007317 2007-008542 2007-007014 2007-007014 2007-007014 2007-007014 2007-007014 2007-008055 2007-009170 2007-008806 2007-008483 2007-007586 2007-008055 2007-008516 2007-007698 2007-008806 2007-007468 2007-000151 2007-007014 2007-000165 2007-009171 2007-008486 2007-008051 2007-009212 2007-007588 2007-000148 2007-000148 2007-008516 2007-008739 2007-000148 2007-000148 2007-003001 2007-003001 2007-008588 2007-007317 2007-001292 2007-001292 2007-008588 2007-007317 2007-008548 2007-008419 2007-008419 2007-008516 2007-008648 2007-000171 2007-009108 2007-009108 2007-000159 2007-009108 2007-000165 2007-008542 2007-008542 2007-009108 SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA 6-7 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Main Electrical Parts List Design LOC Description SEC Code STATUS R800 R801 R802 R803 RFS100 SIM400 TA100 TA200 TA300 TA401 TA402 TA500 TA600 TA601 TA602 TCX200 TR200 TR400 U100 U200 U300 U400 U401 U402 U500 U501 U502 U700 U701 U800 U801 UCP300 UME300 VR300 VR600 VR700 VR701 VR702 VR703 VR704 VR705 VR706 VR707 VR708 VR709 VR710 VR711 VR712 VR713 VR714 VR715 VR716 VR800 R-CHIP R-CHIP R-CHIP R-CHIP CONNECTOR-COAXIAL CONNECTOR-CARD EDGE C-TA,CHIP C-TA,CHIP C-TA,CHIP C-TA,CHIP C-TA,CHIP C-TA,CHIP C-TA,CHIP C-TA,CHIP C-TA,CHIP OSCILLATOR-VCTCXO TR-DIGITAL TR-DIGITAL IC-TRANSCEIVER IC-CMOS LOGIC IC-ANALOG SWITCH IC-VOL. DETECTOR IC-POWER SUPERVISOR IC-BATTERY IC-ANALOG SWITCH IC-AUDIO AMP IC-ANALOG SWITCH IC-MULTI REG. FET-SILICON IC-HALL EFFECT S/W IC-ANALOG SWITCH IC-MODEM IC-MCP THERMISTOR-NTC VARISTOR VARISTOR VARISTOR VARISTOR VARISTOR VARISTOR VARISTOR VARISTOR VARISTOR VARISTOR VARISTOR VARISTOR VARISTOR VARISTOR VARISTOR VARISTOR VARISTOR VARISTOR VARISTOR 2007-008055 2007-001288 2007-001288 2007-008055 3705-001358 3709-001365 2404-001474 2404-001381 2404-001377 2404-001381 2404-001381 2404-001240 2404-001406 2404-001406 2404-001474 2809-001280 0504-001151 0504-000168 1205-003198 0801-002896 1001-001336 1203-004045 1203-004101 1203-003823 1001-001336 1201-002492 1001-001336 1203-004330 0505-001423 1009-001020 1001-001336 1205-003206 1108-000105 1404-001224 1405-001177 1405-001177 1405-001177 1405-001177 1405-001177 1405-001177 1405-001177 1405-001177 1405-001177 1405-001177 1405-001177 1405-001177 1405-001177 1405-001177 1405-001177 1405-001177 1405-001177 1405-001177 1405-001108 SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA SA 6-8 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Main Electrical Parts List Design LOC Description SEC Code STATUS VR801 VR802 VR803 VR804 VR805 VR806 VR807 VR808 VR809 VR810 VR811 VR812 VR813 VR814 VARISTOR VARISTOR VARISTOR VARISTOR VARISTOR VARISTOR VARISTOR VARISTOR VARISTOR VARISTOR VARISTOR VARISTOR VARISTOR VARISTOR 1405-001108 1405-001108 1405-001108 1405-001108 1405-001108 1405-001108 1405-001108 1405-001108 1405-001108 1405-001108 1405-001108 1405-001108 1405-001108 1405-001108 SA SA SA SA SA SA SA SA SA SA SA SA SA SA 6-9 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Main Electrical Parts List 6-10 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization 7. Block Diagrams 7-1. RF Solution Block Diagram 7-1 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Block Diagrams 7-2. Logic Block Diagram 7-2 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization 8. PCB Diagrams Top 8-1 PCB Diagrams Bottom 8-2 9. Flow Chart of Troubleshooting 9-1. Power On ' Power On ' does not work Yes Check the Battery Voltage is more than 3.5V No Change the Battery Yes U401 PIN57(PS_HOLD) = 2.6V? No Check the PMU related to PS_HOLD Yes Check the Clock at OSC400=32.768KHZ? No Resolder OSC400 Yes No Check the PMIC L400(VREG_MSMC) =1.2V? Yes L401(VREG_MSME) = 1.8V? No C421(VREG_MSMP) = 2.6V? Check the PMIC C419(VREG_MSMA) = 2.6V? C410(VREG_TCXO) = 2.8V? Yes No Check for the clock at C405= 19.2 MHz Check the clock generation circuit (TCX200) Yes Check the initial operation Yes END 9-1 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting Power On 9-2 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-2. Initial Initial Failure Yes No PON_RESET_N ="H"? Check the circuit related to reset Yes Not OK Is TP300~309 OK? Check the circuit related to memory OK Check the circuit around LCD & HDC700 (short or unsolder) END 9-3 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-3. Charging Part Abnormal charging part Yes No C607 = 5V ? Resolder IFC600 Yes No Replace U402 U402 pin6 = "L"? Yes Check the Battery & TA Yes END 9-4 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-5 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-4. SIM Part Phone can't access SIM Card Yes No R408 = "H"? Check the SIM POWER Yes No After Power ON, Check SIM_CLK Signal on SIM400 pin3 in a few second Check the 32.768 kHz OSC Yes No After SIM card insert, SIM400 pin 2 = "H(SIM_RST)"? Replace PBA Yes Check the SIM Card OK END 9-6 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-7 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-5. Microphone Part - Phone MIC Microphone does not work Yes Not OK Check the connection from MIC Resolder MIC OK Not OK Check the circuit from UCP300 to MIC Resolder the R503 OK Not OK Check the MIC Replace the MIC OK END 9-8 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-9 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-6 Microphone Part - Earphone MIC Earphone mic. does not work Yes Not OK Check the connection from IFC600 Resolder IFC600 pin 3,4 OK Check the circuit from IFC600 pin 3,4 to UCP300 Not OK Resolder R508, C519, C524 OK No Change a Earphone Is Earphone MIC working? Yes END 9-10 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-11 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-7. Earphone Part Earphone does not work Yes No C514, C516 ≥ 100mV? (When MP3 file is played) Check UCP300 Yes No U502 pin 1A, 2A ≥ 100mV? (When MP3 file is played) Resolder U502, C514, C516 Yes No U501 pin 5, 6 ≥ 200mV? (When MP3 file is played) Resolder U500 Yes Check the circuit from IFC600 pin 5, 6, 7 to U500 Not OK Resolder L602, L603, L604 OK No Resolder IFC600 IFC600 pin 5, 7 short? Yes No Replace the Earphone Is Earphone working? Yes END 9-12 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-13 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-8. Speaker Part Speaker does not work Yes No C513, C515 ≥ 2V? (When MP3 file is played) Check UCP300 Yes No U502 Pin 1A, 2A ≥ 2V? (When MP3 file is played) Resolder U502, C513, C515 Yes No HDC700 Pin 55, 57 ≥ 2V? (When MP3 file is played) Resolder U501 Yes No signal Check the signals of speaker input Check the circuit related to melody signal OK No Is Speaker working? Change the Speaker Yes END 9-14 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-15 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-9. Key Data Input Check Initial Operation Yes No When one of the main keys is pushed, is it displayed on LCD? Check the Dome sheet and Key Fpcb Yes When one of the Navi keys is pushed, dose it work well? No Check the Dome sheet and LCD FPCB Yes END 9-16 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-10. LCD part LCD does not work Yes No Backlight & Navi key are ok? Replace Slide FPCB Yes Pin 39 No LCD_VDD_2.8V at MAIN is Replace MAIN 2.8V? Yes No LCD is always Black? Check HDC700, F700, F701, F702, F703, MAIN Yes Replace the LCD Module OK END 9-17 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-18 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-11. Camera part "Camera" function does not work Yes No Check the Camera connector on LCD module Connect the camera module Yes No HDC700pin 12, 14 = 3.5~4.2V? Check U701 Yes No HDC600 Pin 10, 19, 43 ="H"? (for VGA) Check UCP300, HDC700 Yes No HDC600 Pin 8, 54, 43 = "H"? Check UCP300, HDC700 Yes Is there another problem? Yes Replace the camera module END 9-19 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-20 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-12. LCD Back Light Backlight does not work Yes No Is BACKLIGHT set AlwaysON in the Menu? Set BACKLIGHT on AlwaysON Yes No C700 ≥ 3.5V Replace or Resolder U701 Yes No HDC700 Pin41 ='H'? Check UCP300, HDC700, FOLDER FPCB Yes Replace the LCD Module Yes END 9-21 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-22 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-13. Key Back Light Key Backlight does not work Yes No Is BACKLIGHT set AlwaysON in the Menu? Set BACKLIGHT on AlwaysON Yes No Replace or Resolder U700 KEY_LED_3.3 ≒ 3.3V? Yes Replace the Key FPCB Yes END 9-23 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-24 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-14. GSM Receiver RX ON RF input : CH center freq Amp : -50dBm Yes No C100 ≥ -65dBm Resolder RFS100 Yes No L113 ≥ -70dBm Resolder F100 Yes U100 pin 10,11,12,13 ≥ 500mV No Resolder U100 or Check pins related to U100 Yes Check U100 END 9-25 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-26 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-15. GSM Transmitter TX ON (5 Level) Yes R116 ≥-5dBm No Check RTR6275 Yes C156 ≥-10dBm No Resolder F102 Yes F100 pin25 ≥ 25dBm No Resolder PAM100 Yes C100 ≥25dBm No Replace F100 Yes Check UCP300(MSM) END 9-27 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-28 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-16. DCS Receiver RX ON RF input : CH center freq Amp : -50dBm Yes No L109 ≥ -65dBm Resolder F100 Yes Resolder U101(RTR6275) END 9-29 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-30 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-17. DCS Transmitter TX ON (0 Level) No R120 ≥ -5dBm check RTR6275 Yes No PAM100 pin16 ≥ 20dBm Resolder PAM100 Yes No F100 pin19 ≥ 20dBm Replace F100 Yes Check UCP300(MSM) END 9-31 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-32 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-18. PCS Receiver RX ON RF input : CH center freq Amp : -50dBm Yes No L105 ≥ -65dBm Resolder F100 Yes Resolder U100(RTR6275) END 9-33 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-34 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-19. PCS Transmitter TX ON (0 Level) No R120 ≥ -5dBm check RTR6275 No PAM100 pin16 ≥ 20dBm Resolder PAM100 No F100 pin19 ≥ 20dBm Replace F100 Check UCP300(MSM) END 9-35 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-36 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-20. WCDMA Receiver RX ON Yes Yes C204 ≥ -65dBm Cheak and resolder DUF200 No Yes C135 ≥ -55dBm Cheak and resolder U100 (LNA) No Yes L108 >= -60dBm Resolder F101 (SAW) No Replace U100 (RFR6275) END 9-37 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-38 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-21. WCDMA Transmitter TX ON (PDM for 23dBm) No F200 pin1≥ -10dBm Check U100 (RTR6275) Yes No L201 ≥ -10dBm Resolder F200 (W tx SAW) Yes No Resolder PAM200 C219 ≥ 15dBm Yes No Resolder C203 ≥ 15dBm CPL200 Yes No C202 ≥ 15dBm Resolder DUF200 Yes Check UCP300(MSM) END 9-39 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization Flow Chart of Troubleshooting 9-40 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization