Download Operating Instructions Busch Temperaturregler - Busch
Transcript
1473-1-8396 │ 11.03.2014 Operating Instructions Busch Temperaturregler Pos : 2 /#N eus truktur #/Online-Dokumentation (+KN X)/Titelbl ätter/T emper aturregler/Titelbl att 1099 @ 37\mod_1373543431500_15.doc x @ 298504 @ @ 1 Temperature controllers 1099 UHK 1099 UHKEA === Ende der Liste für T extmar ke Cover === Operating Instructions Busch Temperaturregler Pos : 4 /#N eus truktur #/Online-Dokumentation (+KN X)/Inhalts verz eic hnis (--> Für alle D okumente <--)/Inhalts verz eichnis @ 19\mod_1320649044386_15.doc x @ 109653 @ @ 1 1 2 3 4 5 6 7 8 9 Safety ....................................................................................................................................................................... 3 Intended use ............................................................................................................................................................ 3 Environment ............................................................................................................................................................. 3 Setup and function ................................................................................................................................................... 4 4.1 Features of function and equipment ........................................................................................................ 4 Operation ................................................................................................................................................................. 4 Offset function .......................................................................................................................................................... 5 Technical data.......................................................................................................................................................... 5 Installation and electrical connection ....................................................................................................................... 6 8.1 Requirements for the electrician ............................................................................................................. 6 8.2 Mounting ................................................................................................................................................. 6 8.3 Electrical connection ............................................................................................................................... 8 Commissioning ........................................................................................................................................................ 9 === Ende der Liste für T extmar ke TOC === Operating Instructions | 1473-1-8396 —2— Operating Instructions Busch Temperaturregler Safety Pos : 6 /#N eus truktur #/Online-Dokumentation (+KN X)/Ü bersc hriften (--> Für alle Dokumente <--)/1. Ebene/S - T/Sicherheit @ 18\mod_1302612791790_15.doc x @ 103357 @ 1 @ 1 1 Safety Pos : 7 /#N eus truktur #/Online-Dokumentation (+KN X)/Sicherheits hinweis e und Hi nweis e (--> F ür all e D okumente <--)/Warnhinweis e/Sicherheit - 230 V @ 18\mod_1302606816750_15.doc x @ 103308 @ @ 1 Warning Electric voltage! Risk of death and fire due to electrical voltage of 230 V. – Work on the 230V supply system may only be performed by authorised electricians! – Disconnect the mains power supply prior to installation and/or disassembly! Pos : 8 /#N eus truktur #/Online-Dokumentation (+KN X)/Ü bersc hriften (--> Für alle Dokumente <--)/1. Ebene/A - F/Bes timmungsgemäß er Gebrauc h @ 18\mod_1302763321316_15.doc x @ 103483 @ 1 @ 1 2 Intended use Pos : 9 /#N eus truktur #/Online-Dokumentation (+KN X)/Bes timmungsgemäß er Gebrauc h (--> Für alle Dokumente <--)/Bus ch-Di mmer /Besti mmungsgemäß er Gebr auch @ 23\mod_1335350449857_15.doc x @ 208763 @ @ 1 The device is to be used exclusively with the components that are supplied and licensed as described in chapter "Setup and function". Pos : 10 /#Neustr uktur#/Online-Dokumentati on (+KN X)/Übersc hriften (--> Für all e D okumente <--)/1. Ebene/U - Z/U mwelt @ 18\mod_1302614158967_15.doc x @ 103383 @ 1 @ 1 3 Environment Pos : 11 /#Neustr uktur#/Online-Dokumentati on (+KN X)/Sic herheits hinweise und Hinweis e (--> Für alle Dokumente <--)/Hinweis e - U mwelt/Hi nweis - U mwelt - Hi nweis El ektr ogeräte @ 18\mod_1302763973434_15.doc x @ 103500 @ @ 1 Consider the protection of the environment! Used electric and electronic devices must not be disposed of with domestic waste. – The device contains valuable raw materials which can be recycled. Therefore, dispose of the device at the appropriate collecting depot. Pos : 12 /#Neustr uktur#/Online-Dokumentati on (+KN X)/Sic herheits hinweise und Hinweis e (--> Für alle Dokumente <--)/Hinweis e - U mwelt/Hi nweis - U mwelt - Entsorgung Elektroger äte @ 20\mod_1325760695972_15.doc x @ 136583 @ @ 1 All packaging materials and devices bear the markings and test seals for proper disposal. Always dispose of the packaging material and electric devices and their components via the authorized collecting depots and disposal companies. The products meet the legal requirements, in particular the laws governing electronic and electrical devices and the REACH ordinance. (EU Directive 2002/96/EC WEEE and 2002/95/EC RoHS) (EU REACH ordinance and law for the implementation of the ordinance (EC) No.1907/2006) Pos : 13 /#Neustr uktur#/Online-Dokumentati on (+KN X)/Steuer modul e - Online-Dokumentation (--> Für alle Dokumente <--)/++++++++++++ Seitenumbruc h ++++++++++++ @ 9\mod_1268898668093_0.doc x @ 52149 @ @ 1 Operating Instructions | 1473-1-8396 —3— Operating Instructions Busch Temperaturregler Setup and function Pos : 14 /#Neustr uktur#/Online-Dokumentati on (+KN X)/Übersc hriften (--> Für all e D okumente <--)/1. Ebene/A - F /Aufbau und Funkti on @ 11\mod_1279185435352_15.doc x @ 83027 @ 1 @ 1 4 Setup and function Pos : 15 /#Neustr uktur#/Online-Dokumentati on (+KN X)/Aufbau und Funkti on/T emperaturregler /Ver wendung 1099 @ 37\mod_1373543224390_15.doc x @ 298487 @ @ 1 The temperature controller is used to control the temperature in closed rooms. Application only for de-energized closed actuating drives. Pos : 16 /#Neustr uktur#/Online-Dokumentati on (+KN X)/Übersc hriften (--> Für all e D okumente <--)/2. Ebene/A - F /Funkti ons- und Aus stattungs mer kmal e @ 23\mod_1336557630140_15.doc x @ 209136 @ 2 @ 1 4.1 Features of function and equipment Pos : 17 /#Neustr uktur#/Online-Dokumentati on (+KN X)/Aufbau und Funkti on/T emperaturregler /Funkti onen 1099 @ 37\mod_1373543826093_15.doc x @ 298519 @ @ 1 1099 UHKEA 1099 UHK With manual switch for switchover between cooling/OFF/heating With external input for switchover between heating and cooling. 5 Operation Pos : 18 /#Neustr uktur#/Online-Dokumentati on (+KN X)/Übersc hriften (--> Für all e D okumente <--)/1. Ebene/A - F /Bedi enung @ 11\mod_1279185541649_15.doc x @ 83043 @ 1 @ 1 Pos : 19 /#Neustr uktur#/Online-Dokumentati on (+KN X)/Bedi enung/T emperaturregler /Bedi enung - 1099 @ 37\mod_1373544541890_15.doc x @ 298567 @ @ 1 Pos : 21 /#Neustr uktur#/Online-Dokumentati on (+KN X)/Bedi enung/T emperaturregler /Bedi enung - 1099 @ 37\mod_1373544541890_1.doc x @ 298566 @ 1 @ 4 1099 UHKEA Fig. 1: 1099 UHK Operation No. Function A LED red Operating mode "Heating" LED blue Operating mode "Cooling" B Sliding switch at 1099 UHKEA for selecting function B C Control knob for selecting the desired room temperature Pos : 20 /#Neustr uktur#/Online-Dokumentati on (+KN X)/Steuer modul e - Online-Dokumentation (--> Für alle Dokumente <--)/++++++++++++ Seitenumbruc h ++++++++++++ @ 9\mod_1268898668093_0.doc x @ 52149 @ @ 1 Operating Instructions | 1473-1-8396 —4— Operating Instructions Busch Temperaturregler Offset function Pos : 21 /#Neustr uktur#/Online-Dokumentati on (+KN X)/Übersc hriften (--> Für all e D okumente <--)/1. Ebene/M - O/Offset-Funkti onen @ 37\mod_1373544905078_15.doc x @ 298599 @ 2 @ 1 6 Offset function Pos : 22 /#Neustr uktur#/Online-Dokumentati on (+KN X)/Bedi enung/T emperaturregler /Ei nstellungen Off-Set - 1099 @ 37\mod_1373544852375_15.doc x @ 298583 @ @ 1 Fig. 2: Offset function Reaching the selected room temperature strongly depends on the ambient conditions such as heating/cooling system capacity (5 K/h min.), room size, ambient temperature, insulation etc. That is why the values in the scale are merely guide values. To obtain a setting that is as accurate as possible, the adjusting knob (1) can be offset in 4 stages by a total of +/-6°C. To do so, pull off the control knob and cut off the position lug (2) on its underside using a suitable tool. Then shift the control knob by the desired correction temperature in relation to the vertical and put it back on. Pos : 23 /#Neustr uktur#/Online-Dokumentati on (+KN X)/Übersc hriften (--> Für all e D okumente <--)/1. Ebene/S - T /Technisc he Daten @ 11\mod_1279185386320_15.doc x @ 83019 @ 2 @ 1 7 Technical data Pos : 24 /#Neustr uktur#/Online-Dokumentati on (+KN X)/Technisc he Daten/T emperaturr egler/T echnisc he Daten 1099 @ 37\mod_1373544943578_15.doc x @ 298615 @ @ 1 General Nominal voltage 230 V ~ ±10%, 50 / 60 Hz Switching capacity (inductive) heating 10 (4) A, 230 V ~ Switching capacity (inductive) cooling 5 (2) A, 230 V ~ Connection 1.5 mm² … 2.5 mm² Temperature adjustment range ~ 5 to 30°C (1 = 5°C | 2 = 10°C | 3 = 15°C | 4 = 20°C | 5 = 25°C | 6 = 30°C) Switching temperature difference * Approx. +/- 0.5 K Protection type IP 20, (EN 60529) Power loss (Relay off) 0.5 W Switch contact (independent normally open 2 contact) Mode of operation (DIN EN 60730-1) 1B Degree of contamination (DIN EN 60730-1) 2 Rated surge voltage (DIN EN 60730-1) 4000 V * Typical control operation can not always be attained for cooling areas close to the floor. When the device heats up due to high current loads, the set value should be checked especially in cooling operating mode and, if necessary, the set-point temperature should be raised. Pos : 25 /#Neustr uktur#/Online-Dokumentati on (+KN X)/Steuer modul e - Online-Dokumentation (--> Für alle Dokumente <--)/++++++++++++ Seitenumbruc h ++++++++++++ @ 9\mod_1268898668093_0.doc x @ 52149 @ @ 1 Operating Instructions | 1473-1-8396 —5— Operating Instructions Busch Temperaturregler Installation and electrical connection Pos : 26 /#Neustr uktur#/Online-Dokumentati on (+KN X)/Übersc hriften (--> Für all e D okumente <--)/1. Ebene/M - O/M ontage und el ektrisc her Anschl uss @ 23\mod_1336477157864_15.doc x @ 209033 @ 3 @ 1 8 Installation and electrical connection Pos : 27 /#Neustr uktur#/Online-Dokumentati on (+KN X)/Sic herheits hinweise und Hinweis e (--> Für alle Dokumente <--)/Warnhinweise/Sic herheit - Ni eders pannungs- und 230 V-Leitungen @ 23\mod_1336558868201_15.doc x @ 209164 @ @ 1 Warning Electric voltage! Risk of death due to electrical voltage of 230 V during short-circuit in the low-voltage line. – Low-voltage and 230 V lines must not be installed together in a flush-mounted socket! Pos : 28 /#Neustr uktur#/Online-Dokumentati on (+KN X)/Sic herheits hinweise und Hinweis e (--> Für alle Dokumente <--)/Warnhinweise/Sic herheit - F ac hkenntniss e @ 23\mod_1336559183027_15.doc x @ 209179 @ 2 @ 1 8.1 Requirements for the electrician Warning Electric voltage! Install the device only if you have the necessary electrical engineering knowledge and experience. • Incorrect installation endangers your life and that of the user of the electrical system. • Incorrect installation can cause serious damage to property, e.g. due to fire. The minimum necessary expert knowledge and requirements for the installation are as follows: • Apply the "five safety rules" (DIN VDE 0105, EN 50110): 1. Disconnect from power; 2. Secure against being re-connected; 3. Ensure there is no voltage; 4. Connect to earth and short-circuit; 5. Cover or barricade adjacent live parts. • Use suitable personal protective clothing. • Use only suitable tools and measuring devices. • Check the supply network type (TN system, IT system, TT system) to secure the following power supply conditions (classic connection to ground, protective earthing, necessary additional measures, etc.). Pos : 29 /#Neustr uktur#/Online-Dokumentati on (+KN X)/Übersc hriften (--> Für all e D okumente <--)/2. Ebene/M - O/M ontage @ 18\mod_1302615960458_15.doc x @ 103424 @ 2 @ 1 8.2 Mounting Pos : 30 /#Neustr uktur#/Online-Dokumentati on (+KN X)/Sic herheits hinweise und Hinweis e (--> Für alle Dokumente <--)/Warnhinweise/Sic herheit - 230 V @ 18\mod_1302606816750_15.doc x @ 103308 @ @ 1 Warning Electric voltage! Risk of death and fire due to electrical voltage of 230 V. – Work on the 230V supply system may only be performed by authorised electricians! – Disconnect the mains power supply prior to installation and/or disassembly! Pos : 31 /#Neustr uktur#/Online-Dokumentati on (+KN X)/Steuer modul e - Online-Dokumentation (--> Für alle Dokumente <--)/++++++++++++ Seitenumbruc h ++++++++++++ @ 9\mod_1268898668093_0.doc x @ 52149 @ @ 1 Operating Instructions | 1473-1-8396 —6— Operating Instructions Busch Temperaturregler Installation and electrical connection Pos : 32 /#Neustr uktur#/Online-Dokumentati on (+KN X)/Montage/alle Geräte/M ontage - U P-Dos en - D IN 49073-1 oder geeignetes Aufputzgehaeus e - Ohne Doc vari abl e @ 25\mod_1340354979636_15.doc x @ 219890 @ @ 1 The flush-mounted insert must only be installed in flush-mounted wall boxes according to DIN 49073-1, Part 1, or suitable surface-mounted housings. Pos : 33 /#Neustr uktur#/Online-Dokumentati on (+KN X)/Montage/T emper aturregler/M ontag e 1099 @ 37\mod_1373545684031_15.doc x @ 298631 @ @ 1 Note Use only in dry rooms! Fig. 3: Installation No. Function A Height: 150 cm/minimum distance: 30 cm B Avoid mounting on thermal bridges C Avoid draught and direct sunlight D Avoid the heat radiation of external devices Fig. 4: Position for putting on the adjustment wheel Fig. 5: Putting on the adjustment wheel To put on the adjustment wheel, turn the two arrows towards each other (1). The position lug (3) on the adjustment wheel (2) can now be put on in its normal vertical position. Pos : 34 /#Neustr uktur#/Online-Dokumentati on (+KN X)/Steuer modul e - Online-Dokumentation (--> Für alle Dokumente <--)/++++++++++++ Seitenumbruc h ++++++++++++ @ 9\mod_1268898668093_0.doc x @ 52149 @ @ 1 Operating Instructions | 1473-1-8396 —7— Operating Instructions Busch Temperaturregler Installation and electrical connection Pos : 35 /#Neustr uktur#/Online-Dokumentati on (+KN X)/Übersc hriften (--> Für all e D okumente <--)/2. Ebene/A - F /El ektrisc her Ansc hluss @ 21\mod_1328177051724_15.doc x @ 138042 @ 2 @ 1 8.3 Electrical connection Pos : 36 /#Neustr uktur#/Online-Dokumentati on (+KN X)/Ansc hlus s/T emperaturregl er/Ansc hlus s 1099 @ 37\mod_1373546314562_15.doc x @ 298647 @ @ 1 1099 UHKEA 1099 UHK Fig. 6: Connection to a 2-pipe system Fig. 7: Connection to a 4-pipe system 1099 UHKEA Terminal designation 1099 UHK Assignment Input 1099 UHK for switchover to cooling mode Output for controlling the heating load Output for controlling the cooling load Note At high humidity (tendency toward thunder storms) during cooling mode, attention should be paid to dew formation on the cooled surface. Cooling should be reset early or switched off completely to prevent moisture from damaging the cooled surface. Pos : 37 /#Neustr uktur#/Online-Dokumentati on (+KN X)/Steuer modul e - Online-Dokumentation (--> Für alle Dokumente <--)/++++++++++++ Seitenumbruc h ++++++++++++ @ 9\mod_1268898668093_0.doc x @ 52149 @ @ 1 Operating Instructions | 1473-1-8396 —8— Operating Instructions Busch Temperaturregler Commissioning Pos : 38 /#Neustr uktur#/Online-Dokumentati on (+KN X)/Übersc hriften (--> Für all e D okumente <--)/1. Ebene/G - L/Inbetriebnahme @ 11\mod_1279185496977_15.doc x @ 83035 @ 2 @ 1 9 Commissioning Pos : 39 /#Neustr uktur#/Online-Dokumentati on (+KN X)/Inbetriebnahme/T emperaturregler /Inbetriebnahme - 1099 @ 37\mod_1373547005250_15.doc x @ 298663 @ @ 1 Note When the temperature controller is used for the first time, it has to be taken into account that the switching point precision is not reached until about 1-2 hours of operation after installation. It is recommended to set a temperature that is higher (heating operation) or lower (cooling operation) than actually desired, to reduce the time required for initial adaptation. === Ende der Liste für T extmar ke Content === Operating Instructions | 1473-1-8396 —9— Operating Instructions Busch Temperaturregler A member of the ABB Group Busch-Jaeger Elektro GmbH PO box 58505 Lüdenscheid Freisenbergstraße 2 58513 Lüdenscheid Germany www.BUSCH-JAEGER.de [email protected] Central sales service: Phone: +49 (0) 2351 956-1600 Fax: +49 (0) 2351 956-1700 Notice We reserve the right to at all times make technical changes as well as changes to the contents of this document without prior notice. The detailed specifications agreed to at the time of ordering apply to all orders. ABB accepts no responsibility for possible errors or incompleteness in this document. We reserve all rights to this document and the topics and illustrations contained therein. The document and its contents, or extracts thereof, must not be reproduced, transmitted or reused by third parties without prior written consent by ABB. Copyright© 2014 Busch-Jaeger Elektro GmbH All rights reserved === Ende der Liste für T extmar ke Bac kc over === 1473-1-8396 | 11.03.2014 Pos : 41 /#Neustr uktur#/Online-Dokumentati on (+KN X)/Rüc ksei ten (--> Für alle Dokumente <--)/Rüc ks eite - BJ E-Variante @ 32\mod_1357201421897_15.doc x @ 262132 @ @ 1