Download GE PVB98DTBB Instructions / Assembly

Installation
Instructions
Downdraft Vent Systems
PVB94
PVB98
ZVB30
ZVB36
31-10728-3
07-11 GE
1
Safety Information
BEFORE YOU BEGIN
WARNING:
To reduce the risk
of fire, electric shock or injury to persons,
observe the following.
Read these instructions completely and carefully.
•
IMPORTANT – Save these instructions
A. Use this unit only in the manner intended by
the manufacturer. If you have questions, contact
the manufacturer.
B. Before service or cleaning unit, switch power
off at service panel and lock the service
disconnecting means to prevent power from
being switched on accidentally. When the
service disconnecting means cannot be locked,
securely fasten a prominent warning device,
such as a tag, to the service panel.
for local inspector’s use.
•
IMPORTANT – Observe all governing
codes and ordinances.
• Note to Installer – Be sure to leave these
instructions with the consumer.
• Note to Consumer – Keep these instructions
for future reference.
• Skill Level – Installation of these vents require
basic mechanical and electrical skills.
• Do not attempt to repair or replace any part
of the downdraft system unless it is specifically
recommended in this book. All other servicing
should be performed by a qualified technician.
• Completion Time – 1 to 3 hours.
• Proper installation is the responsibility of the
installer. Product failure due to improper
installation is not covered under the warranty.
• For general ventilating use only. Do not use
to exhaust hazardous or explosive materials
and vapors.
If you received a damaged vent, you should
immediately contact your dealer or builder.
• Installation work and electrical wiring must
be done by a qualified person(s), in accordance
with all applicable codes and standards including
fire-rated construction.
For Monogram local service in your area,
1.800.444.1845.
For Monogram service in Canada,
1.800.561.3344.
For Monogram Parts and Accessories,
call 1.800.626.2002.
CAUTION:
To reduce the risk of fire
and to properly exhaust air, be sure to duct air
outdoors. Do not vent exhaust air into spaces
within walls or ceilings or into attics, crawl spaces
or garages.
WARNING: SHOCK HAZARD
This appliance must be properly grounded.
WARNING:
TO REDUCE THE RISK OF FIRE, USE ONLY METAL
DUCTWORK.
2
Design Information
CONTENTS
Design Information
Product Dimensions.................................................................3
Accessories...................................................................................3
Advance Planning................................................................ 4, 5
Ductwork
Duct Fittings.............................................................................. 10
Installation Instructions
Step 1, Install Downdraft Vent.......................................... 11
Step 2, Install the Ductwork............................................... 11
Step 3, Install Remote Switch............................................ 12
Step 4, Connect Power......................................................... 13
Step 5, Install Filters, Check Operation......................... 13
Cleaning...................................................................................... 13
Installation Preparation
Clearances............................................................................... 6, 7
Parts Supplied.............................................................................7
Tools and Materials Required..............................................7
Remove Packaging...................................................................7
Power Supply...............................................................................8
Venting Options..........................................................................9
PRODUCT DIMENSIONS
30" Models
36" Models
AB
30" 28-5/16"
36" 33-15/16"
ACCESSORIES
JXRB67 – Optional accessory for indoor remote
location of the blower/motor assembly. Use this kit
when the blower and motor assembly will be located
outside of the cabinet, such as below the cabinet floor.
3
'HVLJQ,QIRUPDWLRQ
$'9$1&(3/$11,1*
5HPRWH6ZLWFK
%HIRUH\RXEHJLQ\RXPXVW
7KHDQG0RQRJUDPPRGHOVDQGWKH
DQG3UR¿OHPRGHOVKDYHDVHSDUDWHUDLVHORZHU
VZLWFK3ODQWRLQVWDOOWKHVZLWFKLQDFRQYHQLHQW
ORFDWLRQRXWVLGHRIWKHYHQWFRRNWRSFXWRXW
5HYLHZFRXQWHUWRSGLPHQVLRQLOOXVWUDWLRQVWR
EHVXUH\RXZLOOKDYHHQRXJKÀDWFRXQWHUWRS
VXUIDFH
&KHFNWREHVXUHWKDWWKHWRWDOFRXQWHUWRSGHSWK
UHTXLUHGLQFOXGLQJPLQLPXPFXWRXWWRIURQWHGJH
GHSWKDOORZVHQRXJKVSDFHIRUDEDFNVSODVK
5HYLHZWKHFDELQHWLOOXVWUDWLRQ&KHFNWREHVXUH
WKHLQWHULRUFDELQHWGHSWKZLOOKRXVHWKHFRRNWRS
EXUQHUER[WKHYHQWDQGWKHFXWRXWFOHDUDQFH
IURPWKHIURQW
:KHQFRXQWHUWRSDQGFDELQHWGHSWKSUHVHQW
DSUREOHPUHYLHZ&UHDWLYH6ROXWLRQV
5HDGWKLVERRNFRPSOHWHO\WRDFFXUDWHO\SODQ
WKHLQVWDOODWLRQORFDWLRQFOHDUDQFHVDQG
GXFWZRUNUHTXLUHPHQWV
'RZQGUDIW9HQWDQG&RRNWRS&XWRXW
7KHLQVWDOODWLRQRIWKHVHGRZQGUDIWYHQWVZLWK
DQ\*(RU0RQRJUDPFRRNWRSUHTXLUHVFDUHIXO
FRQVLGHUDWLRQ%HIRUH\RXEHJLQUHYLHZWKH
FRPELQDWLRQFXWRXWLOOXVWUDWLRQVRQSDJH
&RXQWHUWRS5HTXLUHPHQWV
7KHFRXQWHUWRSPXVWKDYHDGHHSÀDWVXUIDFH
WRDFFRPPRGDWHWKHFRRNWRSDQGWKHYHQW
&RXQWHUWRSVZLWKDUROOHGIURQWHGJHDQGEDFNVSODVK
PD\QRWSURYLGHWKHÀDWVXUIDFHDUHDUHTXLUHG
%DVH&DELQHW5HTXLUHPHQWV
:LWKFDUHIXOSODQQLQJ\RXFDQDFKLHYHDFXVWRP
ORRNZLWKPLQLPDODGMXVWPHQWV
7KHEDVHFDELQHWPXVWEHGHHSHQRXJKWR
DFFRPPRGDWHWKHPLQLPXPFOHDUDQFHWRWKHIURQW
RIWKHFRXQWHUWRSWKHFRRNWRSEXUQHUER[
DQGWKHYHQW
&UHDWLYH6ROXWLRQV
Maintain Cutout Clearances
to Front Edge as Specified
‡:KHQWKHNLWFKHQGHVLJQFDOOVIRUDQDJDLQVW
WKHZDOOLQVWDOODWLRQPRYHWKHEDVHFDELQHW
IRUZDUGWR)LOOHUSDQHOVRUFRPSOHPHQWDU\
PROGLQJVFDQEHDGGHGWRH[SRVHGFDELQHWVLGHV
‡,QDQLVODQGRUSHQLQVXODXVHDQH[WUDGHHS
FRXQWHUWRS7KHFRXQWHUWRSRYHUKDQJDWWKH
IURQWFDQEHDGMXVWHGWRPHHWVHWEDFNWRFXWRXW
UHTXLUHPHQWV
‡:KHQWKHFXWRXWWRWKHIURQWHGJHRIWKH
FRXQWHUWRSUHTXLUHPHQWLVPRUHWKDQDGG
DEXOOQRVHWULPWRWKHIURQWHGJHRIWKH
FRXQWHUWRS,QFOXGHWKHWULPWKLFNQHVVZKHQ
PHDVXULQJWKHIURQWHGJHWRFXWRXWUHTXLUHPHQW
%\DGGLQJWKHWULPWKHFRRNWRSFDQEHPRYHG
IRUZDUGSURYLGLQJDGGLWLRQDOFRXQWHUWRSGHSWK
DQGLQWHULRUFDELQHWVSDFH
Filler Panel
Filler Panel
Base
Cabinet
Countertop
Overhang
per Cooktop
Clearances
Must be
Maintained
End
Panel
Cover Panel
Base Sink
'HVLJQ,QIRUPDWLRQ
&OHDUDQFHV
(OHFWULFDODQG*DV/RFDWLRQV
‡7KHGRZQGUDIWV\VWHPZLWKEORZHUPRWRU
DQGGXFWZRUNZLOORFFXS\WKHFDELQHWEHORZ
WKHFRXQWHUWRSDQGFRRNWRS
‡7KHEORZHUPRWRUDVVHPEO\FDQEHORFDWHG
EHORZWKHFDELQHWÀRRU7KHDVVHPEO\ZLOO¿W
EHWZHHQÀRRUMRLVWV2UGHU-;5%IRULQGRRU
UHPRWHORFDWLRQV
‡5HIHUWR\RXUVSHFL¿FFRRNWRSLQVWDOODWLRQ
LQVWUXFWLRQIRUDSSURSULDWHFOHDUDQFHV
‡,QVWDOODWLRQPXVWFRQIRUPZLWKORFDOFRGHV
3ODQWKHSODFHPHQWRIWKHHOHFWULFDORXWOHWDQGJDV
FRQQHFWLRQVLIXVHGFDUHIXOO\(OHFWULFDORXWOHWVDQG
JDVFRQQHFWLRQVFDQQRWEHSODFHGRQWKHEDFNZDOO
RIWKHFDELQHWEHFDXVHLWPD\LQWHUIHUHZLWKWKH
GRZQGUDIWSOHQXP5HIHUWR32:(56833/<VHFWLRQ
IRULQIRUPDWLRQRQORFDWLRQRIHOHFWULFDODQGJDV
FRQQHFWLRQV
‡,QVWDOODVWDQGDUGHOHFWULFDORXWOHWZLWKLQUHDFKRI
WKHYHQW·VWZRIRRWORQJSRZHUFRUG
‡7KHYHQWDQGD*(RU0RQRJUDPJDVFRRNWRS
FRPELQDWLRQFDQRSHUDWHIURPWKHVDPHYROW
VWDQGDUGGXSOH[RXWOHW
‡(OHFWULFFRRNWRSVPXVWRSHUDWHIURPDVHSDUDWH
YROWMXQFWLRQER[
‡$ƒHOERZQRWVXSSOLHGFDQEHLQVWDOOHGRQWRWKH
LQOHWRIWKHJDVFRRNWRSDQGURXWHWKHJDVFRQQHF
WLRQVWRDYRLGLQWHUIHUHQFHZKHQLQVWDOOHGZLWKD
GRZQGUDIWYHQWRURWKHUFDELQHWU\IHDWXUHV
'XFWZRUN
3UHSDUHGXFWZRUNWRYHQWWRWKHRXWGRRUV
‡8VHWKHVKRUWHVWDQGVWUDLJKWHVWGXFWUXQSRVVLEOH
‡7KHPD[LPXPSHUPLVVLEOHHTXLYDOHQWOHQJWKIRU
GXFWUXQLVIHHW
‡5HIHUWR´'XFW)LWWLQJVµFKDUWWRFDOFXODWH
HTXLYDOHQWOHQJWKIRUYDULRXVGXFWFRQ¿JXUDWLRQV
‡7KHGRZQGUDIWEORZHUV\VWHPLVGHVLJQHGWRXVH
[GXFWZRUN,WFDQEHWUDQVLWLRQHGWR
URXQG
‡'XFWZRUN0867EHYHQWHGWRWKHRXWVLGH²QHYHU
LQWRDFUDZOVSDFHDWWLFRURWKHUHQFORVHGVSDFH
‡'HWHUPLQHWKHQHHGIRUDZDOOFDSRUURRIFDS
2UGHUWKHFDSLQDGYDQFH
,QVWDOODWLRQ3UHSDUDWLRQ
&872876$1'&/($5$1&(6
‡0HDVXUHFDUHIXOO\ZKHQFXWWLQJWKHFRXQWHUWRS
‡0DNHVXUHVLGHVRIWKHRSHQLQJDUHSDUDOOHODQG
UHDUDQGIURQWFXWVDUHH[DFWO\SHUSHQGLFXODU
ULJKWDQJOHVWRWKHVLGHV
‡0HDVXUHWREHVXUHWKHUHLVURRPIRUFOHDUDQFHV
WRWKHIURQWHGJHRIWKHFRXQWHUWRS
‡5HIHUWRFRRNWRSLQVWDOODWLRQLQVWUXFWLRQVWREH
VXUHWKDWPRGHOV¿WLQWRWKHEDVHFDELQHWVEHLQJ
XVHG
‡'UDZOLQHVRQWKHFRXQWHUWRSWRIROORZDVD
FXWWLQJJXLGH
‡0HDVXUHDQGPDUNFRRNWRSDQGYHQWRYHUODSVWR
EHVXUHWKHUHLVHQRXJKÀDWFRXQWHUWRSGHSWK
&22.723$1''2:1'5$)7
&20%,1$7,21
7KHFRRNWRSPXVWEHLQVWDOOHGSHUPDQXIDFWXUHU·V
LQVWDOODWLRQLQVWUXFWLRQV
,03257$177KHFRXQWHUWRSFXWRXWGHSWKUHTXLUHV
PLQLPXPÀDWFRXQWHUWRSVXUIDFHDQG
PLQLPXPWRWDOFRXQWHUWRSGHSWK
127(%HIRUH\RXEHJLQPHDVXUHDQGPDUNGHSWK
WRHQVXUHWKDWDGHTXDWHÀDWFRXQWHUWRSVXUIDFH
LVDYDLODEOH
0LQLPXPÀDWFRXQWHU
WRSEHKLQGFXWRXWUHTXLUHG
)RUFRRNWRSDQGGRZQGUDIWFRPELQDWLRQGHSWK
‡)ROORZFRRNWRSLQVWDOODWLRQLQVWUXFWLRQVIRUFRRNWRS
DQGGRZQGUDIWFRPELQDWLRQLQVWDOODWLRQ
‡2WKHUZLVHDGGWRWKHFRRNWRSFXWRXWGHSWK
127($GGWRWKHFRRNWRSFXWRXWGHSWKIRU
-3DQG-3
0LQLPXP
5HTXLUHGWRPDLQWDLQ8/RU&6$DSSURYDOV
&22.723$1''2:1'5$)7
&20%,1$7,21
,03257$177KHFRXQWHUWRSFXWRXWGHSWKUHTXLUHV
PLQLPXPÀDWFRXQWHUWRSVXUIDFHDQG
PLQLPXPWRWDOFRXQWHUWRSGHSWK
127(%HIRUH\RXEHJLQPHDVXUHDQGPDUNGHSWK
WRHQVXUHWKDWDGHTXDWHÀDWFRXQWHUWRSVXUIDFH
LVDYDLODEOH
0LQLPXPÀDWFRXQWHU
WRSEHKLQGFXWRXWUHTXLUHG
)RUFRRNWRSDQGGRZQGUDIWFRPELQDWLRQGHSWK
‡)ROORZFRRNWRSLQVWDOODWLRQLQVWUXFWLRQVIRUFRRNWRS
DQGGRZQGUDIWFRPELQDWLRQLQVWDOODWLRQ
‡2WKHUZLVHDGGWRWKHFRRNWRSFXWRXWGHSWK
127($GGWRWKHFRRNWRSFXWRXWGHSWKIRU
-3DQG-3
0LQLPXP
5HTXLUHGWRPDLQWDLQ8/RU&6$DSSURYDOV
,QVWDOODWLRQ3UHSDUDWLRQ
722/6$1'0$7(5,$/65(48,5('
3$5766833/,('
‡/DUJHÀDWEODGHVFUHZGULYHU
‡-LJVDZ
‡&DUSHQWHU·VVTXDUH
‡'XFWZRUNWRVXLWWKHLQVWDOODWLRQ
‡/HYHO
2SHQWKHFDUWRQDQGUHPRYHSDUWVSDFNDJH
&KHFNFRQWHQWVWREHVXUHDOOSLHFHVDUHSUHVHQW
6WDELOL]LQJ%UDFNHWV
:LWK6FUHZV
5(029(3$&.$*,1*
‡5HPRYHWKHVKLSSLQJPDWHULDOVDQGWKHFDUWRQ
VHWFDUWRQDVLGH7KHFDUWRQFDQEHXVHGDVDSDG
ZKHQFKDQJLQJRUDGMXVWLQJYHQWGLUHFWLRQ
5HPRWH6ZLWFK
)LOWHUV
:LUHDQG:KLWH
&RQQHFWRU
,QVWDOODWLRQ3UHSDUDWLRQ
32:(56833/<
/RFDWHWKH*DVRU(OHFWULFDO
&RQQHFWLRQ2QO\:LWKLQWKH
6KDGHG$UHD
:$51,1*6+2&.+$=$5'
)253(5621$/6$)(7<7+,6$33/,$1&(0867
%(3523(5/<*5281'('
'2127/RFDWH
*DVRU(OHFWULFDO
&RQQHFWLRQVZLWKLQ
WKLV$UHD
5HPRYHKRXVHIXVHRURSHQFLUFXLWEUHDNHUEHIRUH
EHJLQQLQJLQVWDOODWLRQ
IRU0RGHOV
IRU0RGHOV
'RQRWXVHDQH[WHQVLRQFRUGRUDGDSWHUSOXJ
ZLWKWKLVDSSOLDQFH)ROORZ1DWLRQDO(OHFWULFDO&RGH
RUSUHYDLOLQJORFDOFRGHVDQGRUGLQDQFHV
7KLVGRZQGUDIWYHQWPXVWEHVXSSOLHGZLWK9
+]DQGFRQQHFWHGWRDQLQGLYLGXDOSURSHUO\
JURXQGHGEUDQFKFLUFXLWSURWHFWHGE\D
RUDPSHUHFLUFXLWEUHDNHURUWLPHGHOD\IXVH
(OHFWULFDO
2XWOHW
$ERYH
&DELQHW
)ORRU
,03257$17
$SURSHUO\JURXQGHGSURQJUHFHSWDFOHVKRXOG
EHORFDWHGZLWKLQUHDFKRIWKHYHQW·VWZRIRRWSRZHU
FRUG
‡*DV&RRNWRSV
,IWKLVYHQWLVLQVWDOOHGLQFRPELQDWLRQZLWKD*(
RU0RQRJUDPJDVFRRNWRSLWPD\RSHUDWHIURP
WKHVDPHGXSOH[RXWOHW
‡(OHFWULF&RRNWRSV
,IWKLVYHQWLVLQVWDOOHGLQFRPELQDWLRQZLWKD*(
RU0RQRJUDPHOHFWULFFRRNWRSWKHYHQWPXVW
RSHUDWHIURPDVHSDUDWH9RXWOHW
3OHDVHUHDGFDUHIXOO\
7KHSRZHUFRUGRIWKLVDSSOLDQFHLVHTXLSSHG
ZLWKDWKUHHSURQJJURXQGLQJSOXJZKLFKPDWHV
ZLWKDVWDQGDUGWKUHHSURQJJURXQGLQJZDOO
UHFHSWDFOHWRPLQLPL]HWKHSRVVLELOLW\RIHOHFWULF
VKRFN7KHFXVWRPHUVKRXOGKDYHWKHZDOO
UHFHSWDFOHDQGFLUFXLWFKHFNHGE\DTXDOL¿HG
HOHFWULFLDQWRPDNHVXUHWKHUHFHSWDFOHLV
SURSHUO\JURXQGHGDQGKDVFRUUHFWSRODULW\
‡:KHUHDVWDQGDUGWZRSURQJZDOOUHFHSWDFOH
LVHQFRXQWHUHGLWLVWKHSHUVRQDOUHVSRQVLELOLW\
DQGREOLJDWLRQRIWKHFXVWRPHUWRKDYHLW
UHSODFHGZLWKDSURSHUO\JURXQGHGWKUHHSURQJ
ZDOOUHFHSWDFOH
'RQRWXQGHUDQ\FLUFXPVWDQFHVFXWRUUHPRYH
WKHWKLUGJURXQGSURQJIURPWKHSRZHUFRUG
'212786($1(;7(16,21&25'
/RFDWHWKHUHFHSWDFOHLQVLGHWKHFDELQHWRQWKHULJKW
VLGHZDOOVHHLOOXVWUDWLRQ7KHUHFHSWDFOHFDQQRWEH
SODFHGRQWKHEDFNRIWKHFDELQHWZDOOZKHUHLWPD\
LQWHUIHUHZLWKWKHGRZQGUDIWSOHQXP
7KHGRZQGUDIWYHQWSRZHUFRUGLVWREHURXWHG
EHQHDWKWKHFRRNWRSDQGURXWHGDZD\IURPKHDW
JHQHUDWHGE\WKHFRRNWRS
(QVXUHWKDWWKHFRRNWRSLVLQVWDOOHGSHU
PDQXIDFWXUHU·VLQVWDOODWLRQLQVWUXFWLRQV
,QVWDOODWLRQ3UHSDUDWLRQ
9(17,1*237,216
/RRVHQ6FUHZV
WR$GMXVW
WR
/HIWRU5LJKW
‡7KHGRZQGUDIWYHQWLVVKLSSHGZLWKWKH
GLVFKDUJHRXWOHWSRLQWLQJVWUDLJKWGRZQ
DQGFDQEHFKDQJHGWRWKHOHIWRUULJKW
VLGH
‡7KHEORZHURXWOHWLVVL]HGIRU[
DQGFDQEHWUDQVLWLRQHGWRURXQG
6LGHWR6LGH$GMXVWPHQWV
7KHHQWLUHEORZHUPRXQWLQJSODWHFDQEH
DGMXVWHGWRWKHOHIWRUULJKW7KLVZLOO
KHOSWRDOLJQYHQWGLVFKDUJHWRKRXVH
GXFWZRUN
'LVFKDUJH'RZQ
$V6XSSOLHG
'LVFKDUJH'RZQ
$V6XSSOLHG
'LVFKDUJH/HIW
'LVFKDUJH'LUHFWLRQ
'LVFKDUJH5LJKW
7RORFDWHWKHGXFWZRUNKROHVLQWKHFDELQHW
ÀRRURUVLGHZDOOV
7KHEORZHUDVVHPEO\PD\EHUHPRYHGDQGWXUQHG
ƒIRUDOHIWRUULJKWVLGHGLVFKDUJH
‡$OHIWRUULJKWƒGLUHFWLRQDGMXVWPHQWVKRXOGEH
SHUIRUPHGEHIRUHGURSSLQJLQWRWKHFRXQWHUWRS
RSHQLQJ
‡)ODWWHQWKHVKLSSLQJER[WRXVHDVDSDG
‡/D\WKHYHQWRQLWVEDFNDQGRQWRWKHSDG
‡7HPSRUDULO\SODFHYHQWLQWRWKHFRXQWHUWRS
RSHQLQJ
‡3XVKWKHYHQWDOOWKHZD\WRWKHEDFNRIWKH
RSHQLQJ
‡,I\RXDUHWUDQVLWLRQLQJWRURXQGREWDLQHG
ORFDOO\SODFHWUDQVLWLRQSLHFHRYHUWKHGLVFKDUJH
RXWOHW
‡0DUNWKHORFDWLRQDQGUHPRYHWKHDVVHPEO\
‡&XWKROHVDQGLQVWDOOGXFWZRUNFRQQHFWLRQV
‡2UGHU-;5%IRULQVWDOODWLRQRIWKHEORZHUDQG
PRWRUEHORZWKHÀRRU
7RFKDQJHWRDOHIWRUULJKWGLVFKDUJH
‡5HPRYHWKHVFUHZVKROGLQJWKHEORZHUDQG
WKHPRXQWLQJSODWHDVVHPEO\WRWKHGRZQGUDIW
YHQW5HWDLQVFUHZV
‡5HPRYHEORZHUDVVHPEO\WXUQLWRYHUWRDFFHVV
WKHQXWVKROGLQJWKHEORZHUWRWKHPRXQWLQJ
SODWH5HPRYHWKHQXWV
,03257$17'RQRWOLIWPRWRUE\WKHSRZHUFDEOH
‡7XUQWKHEORZHUWRWKHOHIWRUULJKWGLVFKDUJH
GLUHFWLRQDQGUHLQVWDOOWKHQXWV
‡5HLQVWDOOEORZHUDQGPRXQWLQJSODWHZLWKRULJLQDO
VFUHZV
,QVWDOODWLRQ3UHSDUDWLRQ
'8&7
),77,1*6
8VH[
GXFW,WFDQ
WUDQVLWLRQWR
URXQG
8VHWKLVFKDUWWR
FRPSXWHPD[LPXP
SHUPLVVLEOHOHQJWKV
IRUGXFWUXQVWR
RXWGRRUV
127('RQRWH[FHHG
PD[LPXPSHUPLVVLEOH
HTXLYDOHQWOHQJWKV
'RZQGUDIW9HQW
PD[LPXP
HTXLYDOHQWOHQJWK
'XFW3LHFH
'LPHQVLRQV
(TXLYDOHQW
/HQJWK
URXQG
VWUDLJKW
IW
SHUIRRW
OHQJWK
ø[
VWUDLJKW
IW
SHUIRRW
OHQJWK
ƒHOERZ
IW
ƒHOERZ
IW
ø[
ƒHOERZ
IW
)OH[LEOHGXFWLQJ
,IÀH[LEOHPHWDO
GXFWLQJLVXVHGDOOWKH
HTXLYDOHQWIHHWYDOXHV
LQWKHWDEOHVKRXOGEH
GRXEOHG7KHÀH[LEOH
PHWDOGXFWVKRXOGEH
VWUDLJKWDQGVPRRWK
DQGH[WHQGHGDVPXFK
DVSRVVLEOH
ø[
ƒHOERZ
IW
ø[
ƒÀDWHOERZ
IW
'2127XVHÀH[LEOH
SODVWLFGXFWLQJ
URXQG
WRø[
WUDQVLWLRQ
IW
ø[
URXQGWR
WUDQVLWLRQ
IW
URXQGWR
ø[
WUDQVLWLRQ
ƒHOERZ
IW
ø[WR
URXQGWUDQVLWLRQ
ƒHOERZ
IW
URXQG
ZDOOFDS
ZLWKGDPSHU
IW
ø[
ZDOOFDS
ZLWKGDPSHU
IW
URXQG
URRIFDS
IW
127($Q\KRPH
YHQWLODWLRQV\VWHP
VXFKDVDFRRNWRSZLWK
DGRZQGUDIWH[KDXVW
PHFKDQLVPPD\
LQWHUUXSWWKHSURSHU
ÀRZRIFRPEXVWLRQDLU
DQGH[KDXVWUHTXLUHG
E\¿UHSODFHVJDV
IXUQDFHVJDVZDWHU
KHDWHUVDQGRWKHU
QDWXUDOO\YHQWHG
V\VWHPV7RPLQLPL]H
WKHFKDQFHRI
LQWHUUXSWLRQRIVXFK
QDWXUDOO\YHQWHG
V\VWHPVIROORZWKH
KHDWLQJHTXLSPHQW
PDQXIDFWXUHU·V
JXLGHOLQHVDQGVDIHW\
VWDQGDUGVVXFKDV
WKRVHSXEOLVKHGE\
1)3$DQG$6+5$(
$FWXDOOHQJWKRIVWUDLJKWGXFWSOXVGXFW¿WWLQJ
HTXLYDOHQW(TXLYDOHQWOHQJWKRIGXFWSLHFHVLVEDVHG
RQDFWXDOWHVWVFRQGXFWHGE\*((YDOXDWLRQ(QJLQHHULQJ
DQGUHÀHFWUHTXLUHPHQWVIRUJRRGYHQWLQJSHUIRUPDQFH
ZLWKDQ\GRZQGUDIWFRRNWRS
4XDQWLW\
8VHG
7RWDO
(TXLYDOHQW
/HQJWK
7RWDO'XFW5XQ
,QVWDOODWLRQ,QVWUXFWLRQV
,167$//'2:1'5$)79(17
,167$//'8&7:25.
$ 2QHVWDELOL]LQJEUDFNHWPXVWEHLQVWDOOHGRQ
HDFKVLGHRIWKHGRZQGUDIWYHQW
‡)RUULJKWVLGHRUVWUDLJKWGRZQEORZHU
GLVFKDUJHIDVWHQWKHVWDELOL]LQJEUDFNHWVDW
ORFDWLRQV$DQG%
‡)RUOHIWVLGHEORZHUGLVFKDUJHIDVWHQWKH
VWDELOL]LQJEUDFNHWVDWORFDWLRQV%DQG&
‡7KHGRZQGUDIWEORZHUV\VWHPLVGHVLJQHGIRUXVH
ZLWK[GXFWZRUN,WFDQEHWUDQVLWLRQHG
WRURXQG
‡'XFWZRUN0867EHYHQWHGWRWKHRXWVLGH³QHYHU
LQDFUDZOVSDFHDWWLFRURWKHUHQFORVHGVSDFH
‡39&GXFWVKRXOGEHXVHGZKHQLQVWDOOLQJXQGHU
DFRQFUHWHVODE
127(/RFDOEXLOGLQJFRGHPXVWEHIROORZHG
IRULQVWDOODWLRQLQVSHFLI\LQJDSSURYHGW\SHDQG
VFKHGXOHRI39&GXFWXVHG
‡'212786(ÀH[LEOHSODVWLFGXFWLQJ
$
‡$OZD\VXVHDSSURSULDWHURRIRUZDOOFDSZLWK
GDPSHU/DXQGU\W\SHZDOOFDSVVKRXOGQHYHU
EHXVHG
‡8VHWKHVWUDLJKWHVWGXFWUXQSRVVLEOH
‡)RUVDWLVIDFWRU\SHUIRUPDQFHWKHGXFWUXQVKRXOG
QRWH[FHHGIWRULWVHTXLYDOHQWOHQJWKZKHQ
EHQGVRUYDULRXV¿WWLQJVDUHXVHG5HIHUWRWKH
WDEOHRIHTXLYDOHQWOHQJWKVWRFDOFXODWH\RXULQVWDO
ODWLRQ
‡,QVWDOOGXFWZRUNVRWKHSLHFHRIGXFWQHDUHVWWKH
GRZQGUDIWXQLWVORWV,172WKHQH[WSLHFHRIWKH
GXFW6HFXUHWKHMRLQWVZLWKVHOIWDSSLQJVFUHZV
DQGDSSO\GXFWWDSHDURXQGWKHMRLQWVWRHQVXUHDQ
DLUWLJKWVHDO
%
&
$
&
% 3ODFHWKHGRZQGUDIWYHQWLQWRWKHFRXQWHUWRS
FXWRXWVRWKDWWKHEDFNÀDQJHRIWKHYHQWLV
VLWWLQJRQWRSRIWKHFRXQWHUWRS
1RWH7KHGRZQGUDIWYHQWPD\QHHGWREH
WXUQHGDWDQDQJOHWR¿WLQWRWKHFRXQWHUWRS
FXWRXW
& 6HFXUHWKHVFUHZVIRUWKHVWDELOL]LQJEUDFNHWVWR
WKHFDELQHWEDFNZDOO
7239,(:
Duct Tape
Over Seam and Screw
Air
Flow
Screw
&DELQHW%DFN
:DOO
%UDFNHW
/RFDWLRQ$
'RZQGUDIW9HQW
' :KHQLQVWDOOLQJWKHGRZQGUDIWYHQWLQDWLOH
FRXQWHUWRSVXUIDFHLWPD\EHQHFHVVDU\WRDSSO\
DORFDOO\DSSURYHGFDXONLQJWRFRYHUDQ\JDSV
( &KHFNWKDWWKHGRZQGUDIWYHQWLVYHUWLFDOO\OHYHO
2SHUDWHWKHYHQWWRWLPHVWRHQVXUHSURSHU
LQVWDOODWLRQ
,QVWDOODWLRQ,QVWUXFWLRQV
,167$//5(027(6:,7&+
:$51,1*6+2&.+$=$5'
&RQQHFW5HPRWH6ZLWFKWR5HPRWH+DUQHVV
‡7KUHDGWKHUHPRWHKDUQHVVWKURXJKWKHGLD
KROHDQGDWWDFKWKHKDUQHVVFRQQHFWRUWRWKH
UHPRWHFRQQHFWRU
‡5HPRYHWKHSDSHUEDFNLQJRQWKHUHPRWHVZLWFK
IRDPSLHFHDQGPRXQWWKHUHPRWHVZLWFKRQWKH
FRXQWHUWRSVXFKWKDWWKHVZLWFKFRQQHFWRUVVWD\
ORFDWHGLQWKHGLDKROH
‡6WLFNDGKHVLYHZLUHFODPSQHDUWKHGLDKROH
DQGDWWDFKWKHORRVHZLUHZLWKDZLUHWLH
'LVFRQQHFWHOHFWULFDOSRZHUIURPXQLWEHIRUH
EHJLQQLQJVZLWFKLQVWDOODWLRQ)DLOXUHWRGRVRFRXOG
UHVXOWLQSHUVRQDOLQMXU\RUGDPDJHWRWKHHOHFWULFDO
FRQWUROV
:$51,1*%851+$=$5'
7KHUHPRWHVZLWFKPXVWEHORFDWHGVRWKDWLWFDQEH
RSHUDWHGZLWKRXWUHDFKLQJRYHUWKHFRRNWRS)DLOXUH
WRGRVRPD\UHVXOWLQLJQLWLRQRIFORWKLQJZKLFKFRXOG
FDXVHVHULRXVLQMXU\RUGHDWK
'HWHUPLQHWKHORFDWLRQIRUWKHUHPRWHVZLWFK
‡ 7KHUHPRWHVZLWFKVKRXOGEHORFDWHGVRWKDWWKH
YHUWLFDOGLVWDQFHIURPWKHÀRRUWRWKHUHPRWH
VZLWFKLVOHVVWKDQDQGPRUHWKDQ
‡ 7KHUHPRWHVZLWFKKDUQHVVLVORQJDQGVKRXOG
EHLQVWDOOHGVRWKDWLWLVQRWSLQFKHGDQGLVDZD\
IURPPRYLQJSDUWV
6WUDLQ5HOLHI
$GKHVLYHZLUH
FODPSZLWKWLH
Control
Box
0DWLQJ&RQQHFWRUV
5HPRWH+DUQHVV
5HPRWH6ZLWFK
)RDP3LHFH:LWK
$GKHVLYH0RXQWLQJ
6XUIDFH
&RQQHFW:LUH/HDGWR&RQWURO%R[
‡&RQQHFWWKHPDWLQJZLUHHQGV
‡3ODFHWKHDGKHVLYHZLUHFODPSVSURYLGHGQHDU
WKHPDWLQJFRQQHFWRU
‡.HHSDSSUR[LPDWHO\ORQJZLUHDQGDWWDFK
WKHZLUHWRWKHFODPSZLWKDZLUHWLH7KLVZLOODFW
DVDVWUDLQUHOLHI
'LD+ROH
6WUDLQ5HOLHI
$GKHVLYHZLUHFODPS
ZLWKWLH
5HPRWH
+DUQHVV
'LD
+ROH
5HPRWH
6ZLWFK
)RDP3LHFH:LWK$GKHVLYH
0RXQWLQJ6XUIDFH
‡ 'ULOODGLDKROHLQWRWKHGHVLUHGORFDWLRQ8VH
WKHPRXQWLQJEUDFNHWDVDWHPSODWHWRORFDWHWKH
KROHDFFXUDWHO\&KHFNIRULQWHUIHUHQFHEHWZHHQ
WKHVZLWFKFRYHUDGMDFHQWREMHFWVDQGFRRNWRS
YHQWRYHUODSV
‡ ,IVZLWFKLVPRXQWHGLQWRDWLOHVXUIDFHGULOOWKH
KROHEHWZHHQWLOHV8VHORFDOO\DSSURYHGFDXONLQJ
WRFRYHUDQ\JDSV
‡ ,IWKHUHPRWHVZLWFKLVQRWLQVWDOOHGRQWKHFRXQ
WHUWRSHQVXUHWKDWLWLVLQVWDOOHGLQDORFDWLRQWKDW
PHHWVORFDOFRGHVDQGLVHDVLO\DFFHVVLEOH
,QVWDOODWLRQ,QVWUXFWLRQV
&211(&732:(5
3OXJSRZHUFRUGLQWRSURSHUO\JURXQGHGUHFHSWDFOH
,167$//),/7(56&+(&.23(5$7,21
‡3UHVVWKH212))SDGRQWKHFRQWURO
WRUDLVHWKHYHQW
‡6OLS¿QJHUVLQWRWKHYHQWKROHV/LIWWKHYHQW
VWUDLJKWXSDQGSXOOIRUZDUG
5HWDLQHUV
)LOWHU7DEV
‡6OLGH¿OWHULQWRWKHUHWDLQHUVDQGFORVHWKHYHQW
‡3UHVVWKH)DQ6SHHG+,*+(5SDGWRVWDUWWKH
EORZHU$GMXVWWKHEORZHUE\SUHVVLQJ+,*+(5RU
/2:(5
‡7RORZHUWKHYHQWSUHVVWKH212))SDG
127(,WLVQRWQHFHVVDU\WRWXUQWKHIDQ2))
EHIRUHORZHULQJWKHYHQW7KHIDQZLOODXWRPDWLFDOO\
WXUQRȺZKHQWKHYHQWLVORZHUHG:KHQWKHIDQ
LVQRWWXUQHGRȺEHIRUHORZHULQJWKHYHQWLWZLOO
DXWRPDWLFDOO\FRPHRQDWWKHSUHYLRXVO\VHWVSHHG
ZKHQWKHYHQWLVIXOO\UDLVHG
,03257$177KHYHQWFDQEHDFWLYDWHGE\SUHVVLQJ
WKHSDGVRQWKHVZLWFK'RQRWXVHH[FHVVLYHIRUFH
RUVKDUSREMHFWVWRDFWLYDWHWKHVZLWFK'DPDJH
FRXOGRFFXUDQGYRLGWKHZDUUDQW\
1RWHV
1RWHV
127(:KLOHSHUIRUPLQJLQVWDOODWLRQVGHVFULEHGLQWKLVERRN
VDIHW\JODVVHVRUJRJJOHVVKRXOGEHZRUQ
127(3URGXFWLPSURYHPHQWLVDFRQWLQXLQJHQGHDYRU
DW*HQHUDO(OHFWULF7KHUHIRUHPDWHULDOVDSSHDUDQFH
DQGVSHFL¿FDWLRQVDUHVXEMHFWWRFKDQJHZLWKRXWQRWLFH
*(