Download Zenoah RS5B User's Manual
Transcript
5551-93120 POWER SPRAYER RS5B NOTE : 1. Use KOMATSU ZENOAH genuine parts as specified in the parts list for repair and/or replacement. 2. KOMATSU ZENOAH does not warrant the machines, which have been damaged by the use of any parts other than those specified by the company. 3. When placing parts orders for repair and/or replacement, check if the model name and the serial number are applicable to those specified in the parts list, then use parts number described in the parts list. 4. The contents described in the parts list are accurate as of July 1997 and may change due to improvement. 5. The parts for the machine shall be supplied ten (10) years after the machine is discontinued. [It is possible that some specific parts may be subject to change of their delivery term and list price within the limit of ten (10) years after the machine is discontinued. It is also possible that some parts may be available even after the limit of ten (10) years.] APPLICABLE SERIAL NUMBERS : 600001 and up September 1997 RS5B Fig.1 FRAME and TANK GROUP RS5B Fig.1 FRAME and TANK GROUP Key# PART NUMBER 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 2463-21110 2463-21120 2463-21130 2463-21140 2463-21150 2463-21210 0225-00616 01602-20619 0280-10605 01641-20608 5542-82200 5580-83100 2463-21220 2463-21230 2463-21240 2463-21310 2463-21320 2461-21520 2461-21530 2461-21540 2461-21550 2461-21510 2461-21560 2461-21570 2463-21410 2463-21420 2461-21430 2463-21440 2463-21610 2463-21620 2463-21560 2461-21720 5542-73200 2463-21570 2463-25000 2463-25110 2463-25200 2463-25210 2463-25220 2463-25230 2463-25240 2463-25250 2463-25260 2463-25270 2463-25900 2463-25910 2463-25920 2463-25930 2463-25940 2462-25310 2461-25320 2461-25330 2461-25340 2461-25350 2461-25410 2463-25420 DESCRIPTION FRAME,flont FRAME,base SCREW DUMPER,sponge SCREW BRACKET BOLT WASHER NUT WASHER THROTTLE LEVER CABLE STOPPER COLLAR WASHER SWITCH NUT DUMPER NUT WASHER WASHER BASE COLLAR WASHER SCREW WASHER SCREW NUT COVER,frame SCREW BASE,engne DUMPER CORD COMP BOLT TANK ASSY • TANK • CAP ASSY • • CAP • • PACKING • • BREATHER • • STRAINER • • PACKING • • CAP,drain • • PACKING PLATE ASSY • PLATE,side • PLATE,center • BOLT • NUT PAD SCREW WASHER SCREW WASHER HOSE,intake CLIP Q'TY /UNIT 1 1 2 2 1 1 2 2 2 2 1 1 1 1 1 1 1 2 6 6 6 1 3 3 2 2 3 3 1 6 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 2 1 1 1 1 2 2 2 2 1 2 NOTE Key# PART NUMBER 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 2463-25430 2463-25440 2463-25500 2463-25610 2463-25620 01602-20619 2461-25630 2463-25640 2463-25650 2461-25680 2463-25660 2463-25670 2464-25710 2464-25720 2463-25740 DESCRIPTION HOSE CLIP HARNESS ASSY BRACKET SCREW WASHER SCREW BAND SCREW WASHER BAND SCREW LABEL LABEL LABEL Q'TY /UNIT 1 2 1 1 2 4 2 1 1 1 1 1 1 1 1 NOTE RS5B Fig.2 PUMP and NOZZLE GROUP RS5B Fig.2 PUMP and NOZZLE GROUP Key# PART NUMBER 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 2461-11110 2461-12220 2461-11120 2461-11210 2461-12310 2461-11220 2461-11230 2461-12110 2461-12120 2461-11130 2461-12210 2461-12230 2461-12240 2461-12250 2461-12260 2461-12270 2461-12280 2461-12310 2461-12320 2461-12330 2461-12340 2461-12350 2461-12360 2461-12350 2461-12370 2463-12650 2463-25800 2463-25850 2463-25860 2463-25870 2463-25880 2463-25890 DESCRIPTION SHAFT IMPELLER KEY CASE,clutch PIPE CLIP PROTECTOR PUMP BODY COVER SCREW O-RING CLIP COLLAR SEAL SCREW SCREW WASHER PIPE NUT O-RING SOCKET PACKING SOCKET PACKING CAP PACKING NOZZLE COCK PIPE HOSE PACKING PACKING Q'TY /UNIT 1 1 1 1 1 1 1 1 1 4 1 1 1 1 7 1 1 1 2 2 1 1 1 1 1 1 1 1 1 1 2 3 NOTE Key# PART NUMBER DESCRIPTION Q'TY /UNIT NOTE RS5B Fig.3 ENGINE GROUP RS5B Fig.3 ENGINE GROUP Key# PART NUMBER 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 37 36 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 5521-12110 5500-12211 1850-12130 1980-14001 1980-14320 1980-14321 1980-14610 5521-14620 5500-13162 5500-13120 5500-13130 0263-90520 5580-15110 01252-30550 5500-15210 5500-15220 0263-90416 5500-21100 5500-21140 06030-06001 2169-21210 1850-21220 04065-02812 01252-30530 0263-90514 5600-41111 1100-41210 1101-41310 1260-41320 1140-41330 1101-41340 5500-42001 1650-43230 1000-43240 1140-51111 1140-51250 1970-51221 1140-51230 1970-51241 5500-71110 5500-71200 5500-71220 2616-71320 5933-73110 1900-72111 1900-72120 5500-72130 5500-72150 3310-72150 1852-72120 5601-73200 1140-72231 5500-75100 1850-75120 1850-75130 1850-75151 DESCRIPTION Q'TY /UNIT CYLINDER GASKET,base BOLT DECOMPVALVE ASSY • DISK • SPRING WASHER SCREW INSULATOR GASKET,insulator GASKET,carburetor SCREW M5x20 MUFFLER BOLT M5x50 GASKET,muffler PLATE,muffler SCREW M4x16 CRANKCASE COMP GASKET,case BEARING 12x28x8 OIL SEAL 12x22x7 OIL SEAL 12x28x7 SNAP RING ø28 BOLT M5x30 SCREW M5x14 PISTON ø32 RING ø32 PIN ø8 SNAP RING BEARING 8x11x9 THRUST WASHER CRANKSHAFT COMP NUT M8 KEY SHOE,clutch SCREW,clutch SPRING,clutch WASHER,flat WASHER,wave ROTOR COIL ASSY • CORD • CAP,cord SPARKPLUG CAP PLUG SPRING GROMMET SPACER BOLT M4x25 GROMMET CORD COMP CLAMP RECOIL ASSY • REEL • SPRING,spiral • SCREW 1 1 2 1 2 1 1 1 1 1 1 2 1 2 1 1 1 1 1 2 1 1 1 4 1 1 2 1 2 1 2 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 NOTE Key# PART NUMBER 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 BPMR7A 1850-75160 1140-75320 5500-75170 1850-75201 1850-75221 1850-75230 0263-90416 5500-81002 0263-90560 5500-82101 1970-82190 5500-82131 5500-82140 2630-33610 5500-82171 5600-82201 5500-82221 5500-82230 5501-31111 0263-90520 5580-32111 1850-32160 1900-31410 5500-32210 0263-90514 5580-83100 5911-85000 5500-85201 5500-85220 5500-85601 1950-86120 5911-85300 5500-85400 1260-85460 1950-86120 5500-85510 1140-72231 5551-91120 DESCRIPTION Q'TY /UNIT • ROPE • KNOB PLATE PULLY ASSY • RATCHET • SPRING SCREW M4x16 CARBURETOR ASSY SCREW M5x60 BODY ASSY • SLEEVE • PLATE,choke • LEVER,choke • SCREW ø4 CR ELEMENT,filter COVER ASSY • KNOB • RING COVER,fan SCREW M5x20 COVER,engine SCREW M4x12 SCREW ø4 CR GUARD,plug SCREW M5x14 CABLE COMP TANK ASSY • CAP ASSY • • GASKET • BREATHER ASSY • • CLIP • PIPE COMP • FILTER ASSY • CLIP CLIP SCREW M5x16 CLAMP LABEL,recoil 1 1 1 1 1 1 4 1 2 1 2 1 1 1 1 1 1 1 1 4 1 1 2 1 1 1 1 1 1 1 1 1 2 1 1 1 1 1 NOTE RS5B Fig.4 CARBURETOR GROUP Fig.5 TOOL RS5B Fig.4 CARBURETOR GROUP Key# PART NUMBER 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 5500-81002 1752-81110 5500-81120 1751-81130 1881-81140 5500-81153 1918-81170 1751-81180 1881-81130 1751-81240 5500-81251 3310-81260 1065-81410 1065-81420 1850-81450 3306-81380 3356-81310 1850-81270 1850-81220 3310-81250 3310-81230 1850-81470 1850-81490 1751-81510 1850-81520 1850-81530 5500-81160 DESCRIPTION Q'TY /UNIT CARBURETOR ASSY • SCREW • BRACKET • E-RING • SWIVEL • VALVE ASSY • SCREW,adjust • NUT • RING • O-RING • JET • DIAPHRAGM • GASKET,pump • DIAPHRAGM,pump • BODY ASSY • • SCREEN • • VALVE,inlet • • SPRING • • SCREW • • PIN • • LEVER • GASKET • BODY,air purge • PUMP,priming • COVER,pump • SCREW • WASHER 1 2 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 4 1 DESCRIPTION Q'TY /UNIT NOTE Key# PART NUMBER DESCRIPTION Q'TY /UNIT NOTE Key# PART NUMBER DESCRIPTION Q'TY /UNIT NOTE WYJ-81C Fig.5 TOOL Key# PART NUMBER 1 2 1110-91320 3582-91330 SOCKET BAR 1 1 NOTE