Download Sony CDX-MP40 User's Manual

CDX-MP40
SERVICE MANUAL
US Model
Canadian Model
AEP Model
UK Model
Ver 1.0 2003. 01
• The tuner and CD sections have no adjustments.
Model Name Using Similar Mechanism
NEW
AUDIO POWER SPECIFICATIONS (US Model)
POWER OUTPUT AND TOTAL HARMONIC DISTORTION
23.2 watts per channel minimum continuous average power into
4 ohms, 4 channels driven from 20 Hz to 20 kHz with no more
than 5% total harmonic distortion.
CD Drive Mechanism Type
MG-393MC-121
Optical Pick-up Name
KSS-721A
SPECIFICATIONS
Power amplifier section
CD player section
Tuner section
Speaker outputs
(sure seal connectors)
Speaker impedance
4 – 8 ohms
Maximum power output 52 W × 4 (at 4 ohms) (US, Canadian Model)
50 W × 4 (at 4 ohms) (AEP, UK Model)
FM
Tuning range
General
Signal-to-noise ratio
Frequency response
Wow and flutter
Outputs
90 dB
10 – 20,000 Hz
Below measurable limit
87.5 – 107.9 MHz (US, Canadian Model)
87.5 – 108.0 MHz (AEP, UK Model)
Antenna terminal
External antenna connector
Intermediate frequency 10.7 MHz/450 kHz
Usable sensitivity
9 dBf
Selectivity
75 dB at 400 kHz
Signal-to-noise ratio
67 dB (stereo),
69 dB (mono)
Harmonic distortion at 1 kHz
0.5% (stereo),
0.3% (mono)
Separation
35 dB at 1 kHz
Frequency response
30 – 15,000 Hz
Outputs
Inputs
Tone controls
– Continued on next page –
AM (US, Canadian Model)
Tuning range
530 – 1,710 kHz
Antenna terminal
External antenna connector
Intermediate frequency 10.7 MHz/450 kHz
Sensitivity
30 µV
MW/LW (AEP, UK Model)
Tuning range
MW : 531 – 1,602 kHz
LW : 153 – 279 kHz
Aerial terminal
External aerial connector
Intermediate frequency 10.7 MHz/450 kHz
Sensitivity
MW : 30 µV
LW : 40 µV
Audio outputs (front/rear)
Power antenna relay control terminal
Power amplifier control terminal
Telephone ATT control terminal
BUS control input terminal
BUS audio input terminal
Remote controller input terminal
Antenna input terminal
Low: ±10 dB at 60 Hz (XPLOD)
Mid: ±10 dB at 1 kHz (XPLOD)
High: ±10 dB at 10 kHz (XPLOD)
FM/AM COMPACT DISC PLAYER
US, Canadian Model
FM/MW/LW COMPACT DISC PLAYER
AEP, UK Model
9-877-000-01
Sony Corporation
2003A0400-1
© 2003. 01
e Vehicle Company
Published by Sony Engineering Corporation
1
CDX-MP40
Power requirements
Dimensions
Mounting dimensions
Mass
Supplied accessories
12 V DC car battery
(negative ground)
Approx. 178 × 50 × 180 mm
(7 1/8 × 2 × 7 1/8 in.) (w/h/d)
Approx. 182 × 53 × 161 mm
(7 1/4 × 2 1/8 × 6 3/8 in.) (w/h/d)
Approx. 1.2 kg
(2 lb. 10 oz.)
Parts for installation and connections
Front panel case (1)
Card remote commander RM-X115
Note
This unit cannot be connected to a digital preamplifier or an equalizer
which is Sony BUS system compatible.
• US, Canadian model
CAUTION
Use of controls or adjustments or performance of procedures
other than those specified herein may result in hazardous
radiation exposure.
If the optical pick-up block is defective, please replace the whole
optical pick-up block.
Never turn the semi-fixed resistor located at the side of optical
pick-up block.
Design and specifications are subject to change without
notice.
optical pick-up block
SERVICE NOTES
NOTES ON HANDLING THE OPTICAL PICK-UP BLOCK
OR BASE UNIT
The laser diode in the optical pick-up block may suffer electrostatic
breakdown because of the potential difference generated by the
charged electrostatic load, etc. on clothing and the human body.
During repair, pay attention to electrostatic breakdown and also use
the procedure in the printed matter which is included in the repair
parts.
The flexible board is easily damaged and should be handled with
care.
semi-fixed resistor
• AEP, UK model
NOTES ON LASER DIODE EMISSION CHECK
The laser beam on this model is concentrated so as to be focused on
the disc reflective surface by the objective lens in the optical pickup block. Therefore, when checking the laser diode emission, observe from more than 30 cm away from the objective lens.
Notes on Chip Component Replacement
• Never reuse a disconnected chip component.
• Notice that the minus side of a tantalum capacitor may be damaged by heat.
This label is located on the bottom of the chassis.
TEST DISCS
This set can playback CD-R and CD-ROM discs. The following
test discs should be used to check the capability:
This label is located on the drive unit’s internal chassis.
CD-R test disc TCD-R082LMT (Part No. J-2502-063-1)
CD-RW test disc TCD-W082L (Part No. J-2502-063-2)
SAFETY-RELATED COMPONENT WARNING!!
ATTENTION AU COMPOSANT AYANT RAPPORT
À LA SÉCURITÉ!!
COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE
WITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN
THE PARTS LIST ARE CRITICAL TO SAFE OPERATION.
REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE
PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR
IN SUPPLEMENTS PUBLISHED BY SONY.
LES COMPOSANTS IDENTIFIÉS PAR UNE MARQUE 0 SUR LES
DIAGRAMMES SCHÉMATIQUES ET LA LISTE DES PIÈCES
SONT CRITIQUES POUR LA SÉCURITÉ DE FONCTIONNEMENT.
NE REMPLACER CES COMPOSANTS QUE PAR DES PIÈCES
SONY DONT LES NUMÉROS SONT DONNÉS DANS CE MANUEL
OU DANS LES SUPPLÉMENTS PUBLIÉS PAR SONY.
2
CDX-MP40
Notes on CD-Rs (recordable CDs)/CD-RWs (rewritable
CDs)
This unit can play the following discs:
Type of discs
Label on the disc
Audio CD
MP3 files
• Some CD-Rs/CD-RWs (depending on the equipment used for
its recording or the condition of the disc) may not play on this
unit.
• You cannot play a CD-R/CD-RW that is not finalized∗.
• You can play MP3 files recorded on CD-ROMs, CD-Rs, and
CD-RWs.
• A CD-R/CD-RW to which a session can be added can be played.
∗ A process necessary for a recorded CD-R/CD-RW disc to be
played on the audio CD player.
EXTENSION CABLE AND SERVICE POSITION
When repairing or servicing this set, connect the jig (extension cable)
as shown below.
• Connect the MAIN board (CNP701) and the SERVO board (CN1)
with the extension cable (Part No. J-2502-062-1).
MAIN BOARD CNP701
SERVO BOARD CN1
3
CDX-MP40
TABLE OF CONTENTS
1. GENERAL
Location of Controls (US, Canadian Model) .......................... 5
Location of Controls (AEP, UK Model) .................................. 5
Connections (US, Canadian Model) ........................................ 6
Connections (AEP, UK Model) ............................................... 7
2. DISASSEMBLY
2-1. Sub Panel Assy (CD) ........................................................... 9
2-2. CD Mechanism Block ....................................................... 10
2-3. Main Board ....................................................................... 10
2-4. Heat Sink ........................................................................... 11
2-5. Chassis (T) Sub Assy ........................................................ 11
2-6. Lever Section ..................................................................... 12
2-7. Servo Board ....................................................................... 12
2-8. Shaft Roller Assy, Load Sw Board .................................... 13
2-9. Floating Block Assy .......................................................... 14
2-10. Optical Pick-up Block ....................................................... 14
3. DIAGRAMS
3-1. IC Pin Descriptions ........................................................... 15
3-2. Circuit Boards Location .................................................... 20
3-3. Block Diagram –CD Section– ........................................... 21
3-4. Block Diagram –Main Section– ........................................ 22
3-5. Block Diagram –Display Section– .................................... 23
3-6. Printed Wiring Boards –CD Mechanism Section– ............ 24
3-7. Schematic Diagram –CD Mechanism Section (1/2)– ....... 26
3-8. Schematic Diagram –CD Mechanism Section (2/2)– ....... 27
3-9. Printed Wiring Boards –Main Section– ............................ 28
3-10. Schematic Diagram –Main Section (1/2)– ........................ 29
3-11. Schematic Diagram –Main Section (2/2)– ........................ 30
3-12. Printed Wiring Board –Relay Section– ............................. 31
3-13. Printed Wiring Board –Key Section
(US, Canadian Model)– ............... 32
3-14. Schematic Diagram –Relay, Key Section
(US, Canadian Model)– .................. 33
3-15. Printed Wiring Board –Key Section
(AEP, UK Model)– ...................... 34
3-16. Schematic Diagram –Relay, Key Section
(AEP, UK Model)– ......................... 35
3-17. IC Block Diagrams ............................................................ 36
4. EXPLODED VIEWS
4-1.
4-2.
4-3.
4-4.
4-5.
Chassis Section ................................................................. 38
Front Panel Section ........................................................... 39
CD Mechanism Section (1) ............................................... 40
CD Mechanism Section (2) ............................................... 41
CD Mechanism Section (3) ............................................... 42
5. ELECTRICAL PARTS LIST ........................................ 43
4
CDX-MP40
SECTION 1
GENERAL
(US, Canadian Model)
This section is extracted
from instruction manual.
(AEP, UK Model)
5
CDX-MP40
Connections (US, Canadian Model)
6
CDX-MP40
Connections (AEP, UK Model)
7
7
CDX-MP40
8
8
CDX-MP40
SECTION 2
DISASSEMBLY
Note : This set can be disassemble according to the following sequence.
SET
2-5.
CHASSIS (T) SUB ASSY
(Page 11)
CD MECHANISM BLOCK
(Page 10)
2-6.
LEVER SECTION
(Page 12)
2-3.
MAIN BOARD
(Page 10)
2-8.
SHAFT ROLLER ASSY,
LOAD SW BOARD
(Page 13)
2-4.
HEAT SINK
(Page 11)
2-9.
FLOATING BLOCK ASSY
(Page 14)
2-10.
OPTICAL PICK-UP BLOCK
(Page 14)
2-1.
SUB PANEL ASSY (CD)
(Page 9)
2-2.
2-7.
SERVO BOARD
(Page 12)
Note : Follow the disassembly procedure in the numerical order given.
2-1. SUB PANEL ASSY (CD)
2 claws
3 claws
4 CN802
1 PTT 2.6x6
5 sub panel assy (CD)
9
CDX-MP40
2-2. CD MECHANISM BLOCK
7 bracket (CD)
5 CD mechanism block
6 PTT 2.6x6
2 PTT 2.6x6
3
1 PTT 2.6x6
4 CNP701
2-3. MAIN BOARD
5 MAIN board
3 screw (+BTT)
4 screws (+BTT)
2 PTT 2.6x8
1 PTT 2.6x8
10
CDX-MP40
2-4. HEAT SINK
6 heat sink
5 PTT 2.6x8
4 P 2.6x8
3 PTT 2.6x12
2 PTT 2.6x8
1 PTT 2.6x8
2-5. CHASSIS (T) SUB ASSY
2 P 2x3
3 P 2x3
1 Unsoldering three lead wires.
4 chassis (T) sub assy
SERVO board
(SIDE A)
black
red
white
11
CDX-MP40
2-6. LEVER SECTION
5 guide (disc)
6 lever (R)
3 tension spring (LR)
7 lever (L)
1 special screw
2 DISC IN SW board
4 two claws
2-7. SERVO BOARD
9 SERVO board
7 special screws
8 special screw
3 Removal the solders.
2 CN2
5 P2x3
1 CN3
4 Unsolder the
lead wires.
black
yellow
6 loading motor assy
optical pick-up block
12
CDX-MP40
2-8. SHAFT ROLLER ASSY, LOAD SW BOARD
• When installing, take note of the positions
arm (roller) and washers. (Fig. 1)
3 retaining ring (RA)
4 shaft retainer (roller)
arm
shaft retainer (roller)
washer
shaft retainer (roller)
retaining ring (RA) arm washer
Fig. 1
6 special screw
5 shaft roller assy
2 arm (roller)
7 LOAD SW board
1 tension spring (RA)
13
CDX-MP40
2-9. FLOATING BLOCK ASSY
6 floating block assy
7 compression spring (FL)
1 tension spring (KF1)
8 compression spring (FL)
5 Turn loading ring in the
direction of the arrow.
4 Fit lever (D) in the direction of the arrow.
2 damper (T)
3 damper (T)
2-10. OPTICAL PICK-UP BLOCK
1 P 2x3
3 P 2x3
7 PICK-UP FLEXIBLE board
4 plate spring (feed)
2 sled motor assy (M902)
6 shaft (feed) assy
14
5 optical pick-up (KSS-721A)
CDX-MP40
SECTION 3
DIAGRAMS
3-1. IC PIN DESCRIPTIONS
• IC3 HD6432238RWN35TEI (CD MASTER CONTROL) (SERVO BOARD)
Pin No.
Pin Name
I/O
Pin Description
1
TEST
I
Test mode selection pin Not used. (Open)
2
3
DECXRST
DECSTBY
O
O
Reset signal output to the DSP IC “L”: reset
Standby mode control signal output to the DSP IC “H”: standby
4–7
8
NC
PH3
O
I
Not used. (Open)
CD PH3 photo sensor detection signal input
9
10
INSW/PH2
LIMIT_SW
I
I
CD mechanism disc in switch detection signal input
CD mechanism in-limit switch detection signal input
11
12
D_SW
CVCC
I
—
CD mechanism down switch detection signal input
System power supply pin (+3.3 V)
13
14
NC
VSS
O
—
Not used. (Open)
Ground pin
15
16
NC
PH1
O
I
Not used. (Open)
CD PH1 photo sensor detection signal input
17
18
EJECT
LOAD
O
O
CD mechanism loading motor control signal output (eject operation)
CD mechanism loading motor control signal output (load operation)
19 – 26
27
NC
FLAG
O
I
Not used. (Open)
Correction unable detection signal input
28
29, 30
RFOK
NC
I
O
RFOK signal input from the servo IC
Not used. (Open)
31
32
TXD
RXD
O
I
UART TXD PC connection output Not used. (Open)
UART RXD PC connection input Not used. (Open)
33
34
35
XTALEN
TSTB
STB
O
O
O
Crystal oscillation control signal output to the servo IC
CD text parameter strobe signal output to the servo IC
Data strobe signal output to the servo IC
36
A0
O
Command/parameter identification signal output to the servo IC
“L”: command, “H”: parameter
37
38
CD_RST
PACK
O
I
Reset signal output to the servo IC
CD text pack sync signal input from the servo IC
39
40
NC
SELF_SW
O
I
Not used. (Open)
CD mechanism self load position detection switch signal input
41
42
NC
AVSS
O
—
Not used. (Open)
Ground for A/D converter
43, 44
45, 46
NC
NC
O
I
Not used. (Open)
Not used. (Open)
47
48
KEY0
KEY1
I
I
Key switch signal input in the test mode Not used. (Open)
Mode switch signal input in the test mode Not used. (Open)
49 – 52
53
NC
AVREF
I
—
Not used. (Open)
Reference voltage for A/D converter
54
55
AVCC
MD0
—
—
Power supply for A/D converter
CPU operation mode setting pin
56
57
MD1
X1A
—
—
CPU operation mode setting pin Connecting to +3.3 V in this set.
Sub clock oscillator terminal Not used. (Open)
58
59
X0A
RSTX
—
I
Sub clock oscillator terminal Not used. (Open)
Microcomputer reset signal input
60
61
NMI
STBY
—
—
Not used. (Fixed at “H”)
Not used. (Fixed at “H”)
62
63
VCC
XTAL
—
—
Power supply pin (+3.3 V)
Main clock oscillator pin (12.288 MHz)
64
65
VSS
XTEAL
—
—
Ground pin
Main clock oscillator pin (12.288 MHz)
66
FWE
I
Not used. (Open)
Not used. (Open)
Connecting to +3.3 V in this set.
Flash write enable signal input
15
CDX-MP40
Pin No.
67
Pin Name
MD2
I/O
—
68
69
FL_BOOT
FL_W
I
O
Flash write selection signal input (“L”: flash write mode)
Flash write control signal output connected to pin 66 (FWE)
70
71
NC
CDMON
O
O
Not used. (Open)
CD mechanism power supply control signal output
72
73
DECINT
CLOSE
I
O
Interrupt signal input from the DSP IC
Front panel operation request output (Close)
74
75
OPEN
LINKOFF
O
O
Front panel oparation request output (Open)
LINK OFF signal output for UNI_LINK “H”: link off, “L”: link on
76
77
UNI_SO
UNI_SI
O
I
Sony-Bus serial data output to the bus interface
Sony-Bus serial data input from the bus interface
78
79
UNI_CK
NC
I
O
Sony-Bus serial clock input from the bus interface
Not used. (Open)
80
81
SDA
SCL
I/O
O
82
83
NC
TSO
O
O
Not used. (Open)
Serial data output to the servo IC
84
85
TSI
TSCK
I
O
Serial data input from the servo IC
Serial clock output to the servo IC
86
87
LEDDAT
LEDCLK
O
O
LED data output for the jig
LED clock output for the jig
88
89, 90
LEDLAT
NC
O
O
LED latch signal output for the jig
Not used. (Open)
91
92
93
BUSON
BUCHK
A-ATT
I
I
O
Sony-Bus BUS ON signal input from the bus interface
Back up power supply detection signal input
Audio muting control signal output
94
95
CDON
NC
O
O
Power control signal output for the CD servo “H”: servo on, “L”: during loading
Not used. (Open)
96
97
U/J_SEL
TEXTSEL
I
I
Destination setting pin
CD text function setting pin
98
99
NC
CFSEL
O
I
Not used. (Open)
Custom file function setting pin
100
DOUT SEL
I
Digital output selection setting pin
16
Pin Description
CPU operation mode setting pin
I2C interface data input/output
I2C interface clock output
“H”: digital output available
CDX-MP40
• IC5 CXD9684R-005 (DSP) (SERVO BOARD)
Pin No.
Pin Name
I/O
1
/RESET
I
Reset input pin “L”: reset
Pin Description
2
3, 4
MIMD
AD0, AD1
I
O
Microcomputer interface mode selection input
External SRAM address signal output
“H”: I2C, “L”: TSB
5
6
MIDIO (I2C_SDA)
MICK (I2C_SCL)
I/O
I
Serial data input/output
Serial clock input
7
8
AD2
VDDT (3.3V)
O
—
External SRAM address signal output
Power supply (3.3 V) for digital circuit
9
10, 11
SDO
AD3, AD4
O
O
Data output
External SRAM address signal output
12
13
SDI0
BCKIA
I
I
Data input 0
Bit clock input A
14
15
LRCKIA
AD5
I
O
LR clock input A
External SRAM address signal output
16
17
CE
OE
O
O
External SRAM chip enable signal output
External SRAM output enable signal output
18
19
VDD (2.5V)
STANDBY
—
I
Power supply pin (2.5 V) for digital circuit
Standby mode control signal input “H”: STB, “L”: normal
20
21
VSS (2.5VGND)
VSSL (2.5VGND)
—
—
Ground pin for digital circuit
Ground pin for DAC Lch
22
23
VRAL
LO
—
O
Reference voltage pin for DAC Lch
DAC Lch signal output (Open)
24
25
VDAL (2.5V)
VDAR (2.5V)
—
—
Power supply pin (2.5 V) for DAC Lch
Power supply pin (2.5 V) for DAC Rch
26
27
28
RO
VRAR
VSSR (2.5VGND)
O
—
—
DAC Rch signal output (Open)
Reference voltage pin for DAC Rch
Ground pin for DAC Rch
29
30
TESTP
CKS
I
I
31 – 34
35
AD12 to AD9
VDDT (3.3V)
O
—
External SRAM address signal output
Power supply pin (3.3 V) for digital circuit
36 – 38
39
AD8 to AD6
REQ
O
O
External SRAM address signal output
Interrupt request signal output to the CD master control
40
41, 42
VSS
AD13, AD14
—
O
Ground pin for digital circuit
External SRAM address signal output
43
44, 45
WR
AD16, AD15
O
O
External SRAM write signal output
External SRAM address signal output
46, 47
48
IO0, IO1
VSS
I/O
—
External SRAM data input/output
Ground pin for digital circuit
49 – 51
52
IO2 to IO4
VDD (2.5V)
I/O
—
External SRAM data input/output
Power supply pin (2.5 V) for digital circuit
53 – 55
56
IO5 to IO7
VSSP
I/O
—
External SRAM data input/output
Ground pin for VCO circuit
57
58
PDO
VCOI
O
I
PLL phase error detection signal output
VCO control voltage input
59
60
VDDP
XRDE
—
I/O
Power supply pin for VCO circuit
External clock input, audio clock output
61
62
VDDX (2.5V)
XI
—
I
Power supply pin for oscillation circuit
Resonator pin
63
64
XO
VSSX
O
—
Resonator pin
Ground pin for oscillation circuit
Pin for test “H”: test mode, “L”: normal (fixed at “L”)
VCO selection input “H”: VCO, “L”: X1 input
Not used. (Open)
17
CDX-MP40
• IC801 MN101C49KSJ (SYSTEM CONTROL) (MAIN BOARD)
Pin No.
Pin Name
I/O
Pin Description
1
VREF–
—
Power supply pin for A/D converter
2
3
VSM
NIL
I
I
S-meter voltage detection signal input from the tuner unit (TU601)
Not used. (Connected to ground.)
4
5
KEYIN1
KEYIN0
I
I
Key signal input
Key signal input
6
7
RC_IN0
QUALITY
I
I
Rotary commander key signal input from the remote-in jack
Noise detection signal input (AEP, UK model)/Connected to ground. (US, Canadian model)
8
9
DST SEL
NIL
I
I
Destination setting pin (US, Canadian model)
Not used. (Connected to ground.)
10
11
VREF+
VDD
—
—
Power supply pin for A/D converter
Power supply pin
12
13
OSCOUT
OSCIN
O
I
High speed clock output (18.43 MHz)
High speed clock input (18.43 MHz)
14
15
VSS
XIN
—
I
Ground pin
Low speed clock input (32.768 kHz)
16
17
XOUT
MMOD
O
—
Low speed clock output (32.768 kHz)
Memory mode selection input “L”: single chip mode (connected to ground)
18
19
LCDSO
LCDCE
O
O
Serial data output to the LCD driver
Chip enable signal output to the LCD driver
20
21 – 23
LCDCKO
NCO
O
O
Serial clock output to the LCD driver
Not used. (Open)
24
25
SYSRST
BUSON
O
O
System reset signal output
Bus on signal output to the bus interface
26
KEYACK
I
27
DAVN (NIL)
I
Key acknowledge detection signal input
RDS data block sync detection signal input (AEP, UK model)/Connected to
ground. (US, Canadian model)
28
29
BU_IN
SIRCS
I
I
Back up power supply detection signal input
Remote control signal input from the remote control receiver
30
31
TUATT IN
NIL
I
I
ATT control signal input from tuner unit.
Not used. (Connected to ground.)
32
33
NIH
RESET
I
I
Not used. (Connected to power supply.)
Microcomputer reset signal input from the reset IC
34
35
NOSE SW
BEEP
I
O
Front panel with/without detection signal input
Beep signal output to the power amplifier
36
37
NCO
TESTIN
O
I
Not used. (Open)
Test mode detection signal input
38
39
ACCIN
NCO
I
O
Accessory power supply detection signal input
Not used. (Open)
40
41
TELATT
NIH
I
I
TEL ATT detection signal input
Fixed at “H”.
42
43
BUSSO
BUSSI
O
I
Sony_Bus serial data output to the bus interface IC
Sony_Bus serial data input from the bus interface IC
44
45
BUSCKO
I2CSIO
O
I/O
Sony_Bus serial clock output to the bus interface IC
I2C bus serial data input/output
46
47
NCO
I2CCKO
O
O
Not used. (Open)
I2C bus serial clock output
48
49
NCO
NCO
O
O
Not used. (Open)
Not used. (Open)
50
51 – 66
POW_ON
NCO
O
O
System power supply control signal output
Not used. (Open)
67
68
ATT
NCO
O
O
System ATT control signal output
Not used. (Open)
18
“L”: panel with
CDX-MP40
Pin No.
69
Pin Name
TU ON
I/O
O
Pin Description
Tuner power supply control signal output
70
71
VOLATT
NCO
O
O
Electronic volume ATT control signal output to the electronic volume
Not used. (Open)
72
73
AMPON
NCO
O
O
Power amplifier standby control signal output to the power amplifier
Not used. (Open)
74
75
AMPATT
DOORIND
O
O
Power amplifier ATT control signal output to the power amplifier
Sub panel power supply control signal output
76 – 84
85
NCO
NS MASK
O
O
Not used. (Open)
Noise mask signal output
86
87
EE_CKO
EE_SIO
O
I/O
88
89, 90
TUATT
NCO
O
O
Tuner ATT signal output to the tuner unit
Not used. (Open)
91
92
XKEYON
ILL ON
O
O
Power supply control signal to the function key
Illumination power supply control signal output
93
94
NCO
DOORSW
O
I
Not used. (Open)
Front panel open/close detection signal input “L”: close, “H”: open
95
96
DAVSS
NCO
—
O
Ground pin for D/A converter
Not used. (Open)
97
98
FLASH W
RC_IN1
I
I
99
100
NCO
DAVDD
O
—
EEPROM serial clock output
EEPROM serial data input/output
Flash write detection signal input
Remote commander shift key signal input from the remote-in jack “L”: shift key on
Not used. (Connected to ground.)
Power supply pin for D/A converter
19
CDX-MP40
3-2. CIRCUIT BOARDS LOCATION
SERVO board
LIMIT SW board
DISC IN SW board
SPEAKER board
LOAD SW board
tuner unit
(TUX501)
MAIN board
DISPLAY board (US, CND)
KEY board (AEP, UK)
20
RELAY board
CDX-MP40
3-3. BLOCK DIAGRAM — CD SECTION —
IC1
RF AMP,DIGITAL SERVO
DIGITAL SIGNAL PROCESSOR
OPTICAL PICK-UP
KSS-721A
A
84
C
85
(Page 22)
MAIN
SECTION
B
D
RF
EQ
A
B
82
83
FORCUS
ERROR
I/F
E
E
87
86
F
F
TRACKING
ERROR
SERVO
CTL
RFOK
FLAG
PD
97
PD
APC
XTALEN
OSC
LD
DRIVE
Q1
C16M
DIN
A+5V
3
17
14
6
12
8
83 TSO
84 TSI
85 TSCK
5
7
15
62 63 64 65
23
FOCUS
COIL
FCS+
TRK+
TRACKING
COIL
TRK-
15
16
17
18
FOCUS
COIL
DRIVE
TRACKING
COIL
DRIVE
26
11
37 CD_RST
2
23
16
9
4
M
SLSL+
13
14
SLED
MOTOR
DRIVE
5
SP+
M
SP-
11
12
SPINDLE
MOTOR
DRIVE
6
:CD-R/RW(MP3)
33 XTALEN
38
18
29
2
62 X1
/RESET
STANDBY
REQ
MIDIO(I2C_SDA)
9 SDO
12 SDIO
13 BCKIA
1
19
39
5
2
3
72
80
MICK(I2C_SCL) 6
24
X1
16.9344MHz
4
1
81 SCL
MAIN
SECTION
2
DQ1-DQ3, 21-23
IO4-IO8 25-29
20-13
3,2,31
A0-A16 1,12,4
11,7,10
TD
DECXRST
DECSTBY
DECINT
SDA
IC12
14 LRCKIA
A-ATT 93
46,47
49-51 IO0-IO7
53-55
X2
12.288MHz
3,4
7,10
11,15
38-36 AD0-AD16
34-31
41,42
45,44
SW5
(DOWN)
43 WR
17 OE
16 CE
(Page 22)
SW2
(SELF)
11 D_SW
RSTX 59
SW3
(DISC IN)
3
+2.5V
REG
BU+3.3V
SW4
(LIMIT)
9 INSW/PH2
BUSON 91
10 LIMIT_SW
UNI_SI 77
UNI_SO 76
M903
(LOADING)
M
LD-
9
LD+ 10
LOADING
MOTOR
DRIVE
1
LOAD
18 LOAD
EJECT
2
17 EJECT
A+5V
AU+5V
Q916,D927
CD+5V
REG
Q913,914
CDM ON
SWITCH
D925
D+5V
DR+6V
Q912,D926
CD DRIVE+6V
REG
71 CDMON
Q915
CD ON
SWITCH
94 CDON
BATT
21
21
C
(Page 22)
UNI CK 78
2
SYSRST
40 SELF SW
BUCHK 92
+2.5V
(IC5)
B
MAIN
SECTION
SD
MD
A-ATT
63 XTAL
65 EXTAL
IC6
M901
(SPINDLE)
:CD
IC5
DSP
WR 5
CS1 30
OE 32
M902
(SLED)
• Signal path
28 RFOK
27 FLAG
28
IC4
S-RAM
FD
same as L-ch.
36 AO
9
IC2
FOCUS/TRACKING COIL DRIVE,
SLED/SPINDLE/LOADING MOTOR DRIVE
FCS-
• R-ch is omitted due to
35 STB
13
SCKIN
31
SCKO
32
LRCKIN
33
LRCK
34
MD
SD
FD
98
IC3
CD MASTER CONTROL
38 PACK
34 TSTB
30
LD
A
IC7
5V 3.3V
DOUT
TD
LD
CDL
R-CH
PACK
52
TSTB
56
TSCK
55
TSI
54
SI
8
SO
7
SCK
6
STB
5
AO
4
RST
3
DSUB CODE
PROCESS
C
I-V
CONV.
D
LOUT
16
ROUT
12
D/A
CONV
EFM
DEMOD
LINKOFF 75
BU CHK
BUSON
BUS-CLK
BUS-SI
BUS-SO
LINK-OFF
MAIN
SECTION
D
(Page 22)
CDX-MP40
3-4. BLOCK DIAGRAM — MAIN SECTION —
PJ401
L
-1
BUS AUDIO IN
R
R-CH
-2
L
-5
AUDIO OUT FRONT
R
R-CH
-6
L
IC401
INPUT SELECTOR,
ELECTRONIC VOLUME,
SIGNAL PROCESSOR
-3
(Page 21)
CD
SECTION
TU501
TUNER UNIT
PJ601
(ANTENNA)
2 ANT
A
CDR
8 CD R
CDL
9 CD L
L 4
12
5
3
1 FL+
9 FL-
OUT LR 18
11
9
7
2 RL+
10 RL-
Q402
MUTE
Q401
MUTE
16 AUX
OUT RF 21
OUT RR 20
27 SDA
26 SCL
25 MUTE
7 QUALITY
70 VOL ATT
Q602
NS MASK
SWITCH
85 NS_MASK
3 RR+
11 RR-
(Page 21)
CD
SECTION
ATT
BEEP
AMP ON
AMP ATT
TEL ATT
Q904,905
LINE MUTE
SWITCH
A-ATT
B
D921
DELAY
BATT
D701
D819
67
35
72
74
40
Q902
ACC
DETECT
ACC IN 38
2 VSM
45 I2C SIO
47 I2C CKO
TU MUTE 7
MUTE CONDITION 8
SDA(EEP) 17
SCL(EEP) 16
IC902
BU+3.3V
+3.3V
REG
3
TUNER
+5V
Q903,D916
+5V REG
2
BATT
BATT
+8V
Q911,D918,919
TUNER +5V
REG
Q909,910
TUNER ON
SWITCH
87 EE SIO
86 EE CKO
SYSRST
AEP,UK MODEL
13 ATT
7 ACC
BU+5V
TUNER
+8V
88 TU MUTE
30 TU ATT IN
Q901
TEL
ATT
15 TEST
TEST IN 37
S-METER 6
SDA 14
SCL 13
R-CH
R-CH
IC801 (1/2)
SYSTEM CONTROL
QUALITY 5
4 FR+
12 FR-
4 STBY
22 MUTE
R-CH
AEP,UK MODEL
CNP901
OUT LF 19
7 RADIO L
R 3
-4
IC501
POWER AMP
5 AUX L
R-CH
C
IC601
RDS DECODER
Q906,D917
+8V REG
5 AMP R
Q922
ANT B+
SWITCH
BATT
Q921
AMP REM
CONTROL
SWITCH
Q907,908
POWER ON
CONTROL
CD
SECTION
(Page 21)
Q920
AMP B+
SWITCH
Q917
ANT REM
CONTROL
SWITCH
6 ANT R
8
BATT
X601
4.332MHz
4 OSCO
18
16 +B (BATT)
IC802
D810
RESET 33
5 OSCI
DAVN 8
1
27 DAVN(NIL)
BUSON 1
BUSON
CD
SECTION
(Page 21)
D
BUS-SI
BUS-CLK
SYSRST
BUSON
BUSSI
BUSCKO
BUSSO
BU IN
IC701
BUFFER
2
24
25
43
44
42
28
13
12
8
11
9
10
RST
BUSON
DATA OUT
CLK IN
DATA IN
B/U-C
Q802
SWITCH
6
5
4
DATA I/O 6
CLK 4
3
2
1
BATT 3
BATT
Q801,D801
BATT DET
1
Q804
BUS-SO
SWITCH
BUS-SO
LINK-OFF
22
22
BU+5V
• R-ch is omitted due to same as L-ch.
• Signal path
:FM
:CD-R/RW(MP3)
3
7
2
:CD
BATT
D802
D818
S801
RESET
RESET
:AM(MW/LW)
7
RST 2
6
5
CNJ801
BUS
CONTROL IN
8
IC803
BUS INTERFACE
D808
BU-CHECK
19
F901
10A
POW ON 50
SDA 9
SCL 10
GND
17
TU ON 69
16 MPX
RDS DET 9
AUDIO OUT REAR
R
R-CH
Q805,806
LIMNKOFF
SWITCH
BATT
CDX-MP40
3-5. BLOCK DIAGRAM — DISPLAY SECTION —
IC801 (2/2)
SYSTEM CONTROL
AEP,UK :S902,903,931,LSW901(1/2),904(1/2)-910(1/2)
US,CND:S901,903,931,LSW901(1/2)-907(1/2)
FUNCTION SWITCH
THIS NOTE IS COMMON FOR PRINTED WIRING
BOARDS AND SCHEMATIC DIAGRAMS.
(In addition to this, the necessary note is
printed in each block.)
IC901
LCD DRIVER
(US,Canadian MODEL)
(AEP,UK MODEL)
for schematic diagram:
• All capacitors are in µF unless otherwise noted. pF: µµF
50 WV or less are not indicated except for electrolytics
and tantalums.
• All resistors are in Ω and 1/4 W or less unless otherwise
specified.
•
%
: indicates tolerance.
f
•
: internal component.
• C : panel designation.
Note:
Note:
The components identi- Les composants identifiés par
fied by mark 0 or dotted une marque 0 sont critiques
line with mark 0 are criti- pour la sécurité.
Ne les remplacer que par une
cal for safety.
Replace only with part piéce portant le numéro
spécifié.
number specified.
5 KEY IN0
LCDSO 18
LCDCKO 20
LCDCE 19
AEP,UK :S911,LSW912(1/2)-922(1/2)
US,CND:S902,LSW908(1/2)-917(1/2)
FUNCTION SWITCH
78 DATA
77 CLK
76 CE
S1 1
I
I
S64 64
LCD901
LIQUID
CRYSTAL
DISPLAY
4 KEY IN1
COM1 65
|
|
COM4 68
D809
Q803
KEY
DETECT
26 KEY ACK
91 XKEYON
DOOR
75
IND
BATT
D807
ILLON 92
BATT
2
ILL B+
Q919
ILL ON
SWITCH
IC951(US,Canadian MODEL)
IC971(AEP,UK MODEL)
REMOTE
CONTROL
RECEIVER
DOOR IND
SW
Q923,924
98 RC IN1
6 RC IN0
CNP801
(REMOTE IN)
• A : B+ Line.
• Power voltage is dc 14.4V and fed with regulated dc power
supply from ACC and BATT cords.
• Voltages are taken with a VOM (Input impedance 10 MΩ).
Voltage variations may be noted due to normal production tolerances.
• Waveforms are taken with a oscilloscope.
Voltage variations may be noted due to normal production tolerances.
• Circled numbers refer to waveforms.
• Signal path.
F : FM
f : AM/MW/LW
J : CD
c : CD-R/RW (MP3)
LED930,931
29 SIRCS
AEP,UK :LED933,934
US,CND:LED910,911
Q918
ILL B+
SWITCH
(
LCD BACK
LIGHT
)
AEP,UK :LED903,911,951-954,LSW901(2/2),
904(2/2)-910(2/2),912(2/2)-922(2/2)
US,CND:LED901-906,LSW901(2/2)-917(2/2)
34 NOSE SW
KEY
( ILLUMINATION
)
S802
(NOSE DET)
X802
32.768kHz
15 XIN
16 XOUT
OSC OUT 12
OSC IN 13
• Waveforms
— SERVO Board —
— MAIN Board —
(MODE: CD PLAY)
1
1V/DIV,20ns/DIV
230 ns
IC1 wd (XTAL)
2
X801
18.432MHz
Caution:
Pattern face side:
(Side B)
Parts face side:
(Side A)
23
23
Parts on the pattern face side seen from the
pattern face are indicated.
Parts on the parts face side seen from the
parts face are indicated.
7
1.7 Vp-p
IC1 oa (FEO)
54 ns
100mV/DIV,20µs/DIV
1V/DIV,40ns/DIV
82 ns
IC3 yd (XTAL)
3.2 Vp-p
8
2V/DIV,20µs/DIV
30.5 µs
3.8 Vp-p
IC801 qh (XOUT)
IC1 od (TEO)
5
2V/DIV,40ns/DIV
IC801 qs (OSCOUT)
100mV/DIV,20µs/DIV
Approx. 200m Vp-p
4
5.5 Vp-p
IC601 4 (OSCD)
500mV/DIV,1µs/DIV
IC1 uj (RFO)
3
2V/DIV,100ns/DIV
2.8 Vp-p
59 ns
Approx. 300m Vp-p
for printed wiring boards:
• X : parts extracted from the component side.
• Y : parts extracted from the conductor side.
•
x
: parts mounted on the conductor side.
a
•
: Through hole.
•
: Pattern from the side which enables seeing.
(The other layer’s patterns are not indicated.)
6
1.2 Vp-p
CDX-MP40
3-6. PRINTED WIRING BOARDS — CD MECHANISM SECTION — • Refer to page 20 for Circuit Boards Location.
13
12
11
10
9
8
7
6
5
4
3
2
R115
R104
R113
JR8
C6
C3
C
R3
): SIDE B
C16
C78
D
R105
JR5
JR17
C25
C34
C29
C65
JR6
C112
C44
C114
R114
R121
C15
C20
C23
R9
R8
L6
R5
IC6
E
R107
IC12
C36
L4
C70
C60
C62
R130
R97
C69
R77
C53
R92
R45
C57
R94
R47
R46
R73
R67
C22
F
R76
R54
R91
C54
C102
R154
C75
C81
C30
C67
R55
C79
FB6
C63
R90
C51
C77
L8
C38
G
R48
JR21
C35
R65
C19
R106
R13
C111
R26
Q1
JR3
C-8
R98
(Q1)
B
R152
Location
E-8
H-8
D-3
G-2
G-4
E-3
F-6
E-4
C24
(
Ref. No.
IC1
IC2
IC3
IC4
IC5
(IC6)
IC7
(IC12)
1
A
• Semiconductor
Location
C13
14
C55
C58
R7
JR14
H
I
24
24
CDX-MP40
2
1
3
4
5
6
7
8
9
10
11
12
13
14
A
CN
2
R30
C5
C1
B
C43
R29
C
R118
R111
C39
C40
JR1
R153
R131
R134
R147
RB1
R85
C56
R52
R51
R69
RB2
R83
R68
R82
JR12
R70
C68
R144
SW4
R15
R133
R135
R14
R145
R53
IC5
R64
H
R143
R93
R95
R96
R87
R49
R81
R86
R84
G
X1
IC7
R74
R72
R71
R75
IC4
SW5
R132
C59
JR15
F
SW2
FB2
C61
IC1
C27
R149
R136
R151
R150 R103
R129
R78
C113
C17
C45 C41
R124
E
SW3
R102
JR13
X2
(Page 28)
C18
R148
IC3
R128
C14
C8
R119
R126
R127
C9
FB3
C10
CN1
R117
D
C11
C4
R116
R109
R100
R12 R10
R142
R146
CN13
IC2
R88
R89
R50
C21
CN3
I
25
25
CDX-MP40
• Refer to page 23 for Waveforms.
3-7. SCHEMATIC DIAGRAM — CD MECHANISM SECTION (1/2) — • Refer to page 36 for IC Block Diagram.
Note:
• Voltage is dc with respect to ground under no-signal
conditions.
no mark : CD PLAY
: Impossible to measure
∗
M902
SW4
CN13
TP78
TP77
TP79
TP81
TP80
TP84
TP83
TP82
CN2
CN3
R26
R29
TP8
R3
R13
C5
C4
C43
R30
C1
C6
TP9
C59
IC6
L6
C65
Q1
C3
C60
L8
R152
C19
C24
IC7
L4
TP88
TP22
TP23
TP24
TP25
R8
R9
C18
R153
FB2
C20
C23
TP89
IC4
C61
C35
C68
C62
TP10
R5
TP45
TP44
C14
C13
C67
C63
TP43
TP42
TP41
JR21
C77
C11
C56
C57
C81
TP40
R82
TP39
TP38
R83
R84
R69
JR14
IC1
R65
FB6
R85
R68
C58
R70
RB2
R64
TP37
TP7 C15
C55
C38
C10
R88
TP11
R144
R67
R142
C9
R89
JR12
TP36
TP12
CN1
C54
TP50
RB1
TP51
R146
C8
R50
TP53
JR13
TP54
TP55
R49
R145
R147
R143
R98
R97
C36
TP52
R86
R87
R51
TP56
R81
R52
IC5
C16
R96
R48
TP57
R95
R94
R47
TP58
R46
R93
R78
R77
R76
R53
R54
IC B/D
X1
TP59
R45
R116
TP62
TP63
TP64
R75
C53
R74
R55
TP66
C34
R90
C44
JR15
C29
TP95
TP70
TP71
R71
R72
TP72
TP73
C69
TP74
R92
C75
C51
C40
R149
C17
R151
(Page 30)
TP67
TP68
R91
TP94
C78
C25
R150
R148
R73
C39
TP60
TP61
R117
R118
C27
C45
TP76
TP75
C79
C41
JR3
TP49
JR6
JR5
JR1
TP65
FB3
(Page 27)
(Page 27)
26
26
CDX-MP40
• Refer to page 23 for Waveform.
3-8. SCHEMATIC DIAGRAM — CD MECHANISM SECTION (2/2) — • Refer to page 36 for IC Block Diagrams.
(Page 26)
R105
(Page 26)
TP4
TP3
TP2
TP1
R126
C114
R128
R127
SW3
SW2
TP92
IC B/D
TP31 TP33
R109
BP1
R111
BP2
TP30 TP32
SW5
R113
R7
R15
R154
TP15
BP3
R12
TP21
R14
MD14
R10
BP4 TP18
C22
R130
R104
R133
R134
R115
C111
R135
R136
IC2
C21
C30
TP16
TP19
TP26
TP28
IC12
C70
R131
TP91
R129
R132
R107
R106
R119
R124
C112
BP6
R102
C113
X2
R121
R114
R103
TP27
TP29
BP5
TP86
TP17
TP20
C102
JR17
IC3
TP90
TP87
M903
IC B/D
R100
Note:
• Voltage is dc with respect to ground under no-signal
conditions.
no mark : CD PLAY
: Impossible to measure
∗
27
27
CDX-MP40
• Refer to page 20 for Circuit Boards Location.
3-9. PRINTED WIRING BOARDS — MAIN SECTION — • Refer to page 30 for Semiconductor Location.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
PJ401
A
CNP801
PJ601
CNJ801
JW132
F901
C415
D906
R807
C901
D909
C822
R930
JW8
JW9
JW11
R922
R801
R914
Q918
D801
JW55
Q801
R918
C818
C917
C815
JR806
R812
JW160
C807
Q919
JW52
Q803
R831
C918
Q907
JW58
R867
C814
JW168
JW50
JW10
JR904
C806
R866
JW191
C817
IC802
JW62
JW36
JW103
02
X8
C809
C808
D925
C812
FB801
D808
C716
R816
JW59
C823
R834
FB701
J
(Page 31)
28
28
S802
JW1
C827
JW2
R832
R833
R828
JW65
JW66
JW111
IC803
JW46
JW53
JW48
JW45
JW44
R705
R706
R702
D920
C825
JW54
Q805
X801
FMB5
D917
R802
R811
C826
JW174
C811
D811
D814
D815
D812
D813
C805
C813
Q906
R915
Q913
Q916
L701
R814
R815
S801
D817
D926
R904
R901
R908
D916
C719
C204
JR805
JW139
R825
R923
JW68
R910
C909
JW42
D901
D903
D904
D902
D908
C203
C206
C802
IC801
C810
JW150
D807
JW69
JW70
JW74
JW67
R813
R836
Q908
R843
D802
JW172
CNP802
R868
JW49
(Page 25)
Q921
Q915
JW98
C821
R819
Q802
Q804
R826
Q806
JR803
R821
R870
AEP,UK Model
Q920
JW38
D810
R824
JW64
JW173
JW108
JW72
JW76
JW109
JW75
JW79
JW78
JR801
JR601
JW97
JW85
D809
R835
R817
R818
D816
JR602
R823
R822
C618
C615
JW73
C704
D818
JW135
JW102
R820
JW81
CNP701
JW41
JW142
X601
IC601
Q602
R620
JW4
C816
JW151
C624
JW116
R830
R607
JW86
FMB6
JW100
JW88
R829
R609
JW5
D819
JW141
C617
IC701
JW80
JW190
TH901
R707
R911
JW89
C616
R612
C705
R827
JW107
JW159
JW158
JW83
JW84
JW101
FB601
JW125
R934
JW37
JW40
R708
JW90
C922
R931
D701
JW118
R608
Q922
JW47
C718
C207
Q911
C621
I
JW43
JW51
JW520
JW152
JW39
Q910
D927
C715
R935
JW34
Q917
L702
C712
JW134
IC902
C106
C623
JW128
R204
JW110
C202
JW96
H
JW114
C215
JR116
R505
C622
JW99
C211
JW106
JW82
JW115
JW61
R927
C205
C208
R102
JW117
C210
C713
R924
JW124
R926
Q914
Q909
D804
JW33
Q903
JW35
C703
D805
JW32
L703
R203
JW19
R804
JW31
C910
R103
R925
JW87
C209
IC401
JW136
D919
D918
JW95
C506
C920
JW200
R112
R913
L900
JW18
D806
R909
JW15
JW16
JW17
JW22
C714
JW138
JR405
C902
JW21
JW122
R111
C507
Q901
D915
JW121
C101
E
Q923
JW120
R202
R502
G
JW140
C109
C701
C702
C505
R201
R104
C503
R907
R932
JW123
Q924 JW56
L704
R101
R906
JW14
R805
JW20
Q902
JR906
C201
F
JW71
R417
D921
US,Canadian Model
C916
JW30
D911
D910
JW57
R418
R404
R403
R401
R402
JW112
C212
D
C426
R419
C717
Q912
JW137
TH900
C905
JW29
C907
Q905
R420
C425
C423
C427
TUX501
Q904
C411
C401
C403
C402
C213
C629
C404
C409
C429
JW28
C413
R903
D912
JW27
R905
C406
D923
JR807
C412
R411
JW131
R405
C407
JW127
R407
JW13
C804
JW26
D905
Q403
C428
R409
JW25
R806
JW12
JW3
C405
JW205
JW207
JW208
JW24
C408
JW143
JW130
JW23
JW91
C424
JR403
Q402
JW7
JW6
C
Q404
JW129
Q401
R410
R408
R412
C419
R415
R416
JR402
IC501
JW201
JW203
JW204
JW206
JR115
R406
C418
JW202
D907
C421
R414
CNP901
C803
JW126
JW133
C420
C416
R413
B
C417
JR401
CDX-MP40
• Refer to page 23 for Waveform.
3-10. SCHEMATIC DIAGRAM — MAIN SECTION (1/2) — • Refer to page 36 for IC Block Diagrams.
PJ601
C629
JR601
Q602
PJ401
R620
C421
C420
C717
JW87
IC B/D
IC401
JW82
C503
C419
R103
R102
C215
C213
JW96
R502
C418
C106
R112
C429
R416 R415 C417
C428
R414 R413 C416
C212
C505
C506
R111
C211
C210
R204
R404
R403
R401
TUX501
R203
C204
C203
C208 C209
R402
R202
C507
JR401
C101
C205
C201
C206
C109
R101 R104
R201
R505
C207
C701 L704
C702
C202
C415
C413
IC501
D901
IC B/D
D902
C401
R405
C405
Q401
R406
D903
C424
C615 C617 C618
C425
R408
FB601
C402
X601
R607
C406
D905
R609
CNP901
C616
R608
D904
Q402
R407
D906
C403
C407
R409
Q403
R410
D907
C426
IC601
C427
R412
C404
D908
Q404
R411
C408
R612
C624
C621
R901
C623
Q904
R903
D921
C622
C412
C907
C409
R904
Q905
R417
R932
C423
R418
C905
R420
R419
C902
L900
D912
C411
D911
D910
D923
R905
Q911
Q906
Q909
Q907
R925
R923
C918
Q910
C917
R930
R935
R922
D917
D919
R934
Q902
R913
Q908
C922
R909
C814
C817
C807
D916
R924
C920
R906
R911
Q901
IC802
R811
D918
D915
C901
Q922
Q920
TH901
Q903
F901
D909
C806
C910
R910
(Page 30)
C909
Q921
R908
R931
Q917
R907
Note:
• Voltage is dc with respect to ground under no-signal
conditions.
no mark : FM
(
) : AM/MW/LW
29
29
CDX-MP40
• Refer to page 23 for Waveforms.
3-11. SCHEMATIC DIAGRAM — MAIN SECTION (2/2) — • Refer to page 36 for IC Block Diagram.
(Page 29)
R707
R706
R801
R802
D801
D802
R705
IC701
C716
D808
IC902
Q801
C718
D818
R824
R823
C818
R821
C812
CNJ801
C813
R822
Q803
R826
C821
R827
D920
TH900
FB801
CNP701
R702
D804
IC803
D805
IC B/D
D810
D806
C715
Q804
C802
R804
R805
C804
C805
C803
R868
R812
R843
C704
R708
C815
R825
Q802
R867
R866
Q805
D701
Q806
R806
R813
C705
L701
R807
Q918
X802
C816
C808
C809
(Page
26)
IC801
C719
CNP801
R814
R815
D807
R918
12
2W
C822
R816
C712
C823
R914
Q923
R915
X801
D819
JR801
Q919
D809
L702
Q924
R817
R818
R820
JR906
JR805
C713
R819
C703 C714 L703
C810
CNP802
R834
R833
R832
R830
Q916
R829
Q912
(Page 33)
C825
Q913
R836
R870
R831
R828
R927
R926
C826
R835
D925
D812
C811
D811
D813
D815
S802
D817
C916
D814
S801
D927
D926
(Page 35)
C827
Q914
D816
Q915
JW174
FB701
• Semiconductor Location
Ref. No.
D701
D801
D802
D804
D805
D806
D807
D808
D809
D810
D811
D812
D813
Location
F-5
G-9
G-9
D-9
D-9
D-9
I-4
G-8
I-2
G-8
J-3
J-2
J-2
Ref. No.
D814
D815
D816
D817
D818
D819
D901
D902
D903
D904
D905
D906
D907
Location
J-3
J-3
I-2
J-2
G-8
F-5
C-6
C-6
C-6
C-6
C-5
B-7
B-7
Ref. No.
D908
D909
D910
D911
D912
D915
D916
D917
D918
D919
D920
D921
D923
Location
C-5
C-9
D-8
C-8
C-8
D-6
E-7
G-10
F-2
E-2
G-6
D-5
C-7
Ref. No.
D925
D926
D927
Location
G-9
C-10
E-7
IC401
IC501
IC601
IC701
IC801
IC802
IC803
IC902
E-3
B-5
H-3
F-7
H-7
I-10
F-9
F-4
Ref. No.
Q401
Q402
Q403
Q404
Q602
Q801
Q802
Q803
Q804
Q805
Q806
Q901
Location
C-4
C-3
C-3
C-4
H-3
H-9
F-9
H-8
F-9
G-9
F-9
D-6
Ref. No.
Q902
Q903
Q904
Q905
Q906
Q907
Q908
Q909
Q910
Q911
Q912
Q913
30
Location
D-6
E-7
D-5
D-5
F-10
G-9
F-10
D-9
E-9
F-2
C-10
E-8
30
Ref. No.
Q914
Q915
Q916
Q917
Q918
Q919
Q920
Q921
Q922
Q923
Q924
Location
E-7
G-9
E-7
E-9
G-10
H-10
E-10
F-10
F-8
D-5
D-4
Note:
• Voltage is dc with respect to ground under no-signal
conditions.
no mark : FM
(
) : AM/MW/LW
<
> : CD PLAY
CDX-MP40
3-12. PRINTED WIRING BOARD — RELAY SECTION — • Refer to page 20 for Circuit Boards Location.
1
2
3
4
5
6
7
8
9
(Page 32)
A
(Page 34)
B
C
LED931
R932
CNP902
R931
R930
LED930
D
S931
E
FMA3
F
(Page 28)
G
J
31
31
D907
D906
D905
D903
I
D902
C974
C973
D904
H
D901
CNP903
10
CDX-MP40
3-13. PRINTED WIRING BOARD — KEY SECTION (US, Canadian MODEL) — • Refer to page 20 for Circuit Boards Location.
2
1
3
4
5
6
7
8
9
10
11
12
13
14
A
LED901
LSW913
S901
B
LSW903
LED905
LSW911
LSW904
LED911
LED904
LED910
C
LED902
LED906
LCD901
LED903
S902
LSW906
IC951
S903
LSW912
LSW905
LSW902
LSW901
D
LSW907
LSW908
LSW917
LSW910
LSW909
LSW915
LSW916
LSW914
E
R974
R915
R912
R913
R901
D907
R943
D951
CN901
C951
C954
FMB6
R973
R983
R981
I
• Semiconductor Location
J
Ref. No.
D901
D902
D903
D904
D905
Location
H-10
H-10
H-10
H-10
G-10
Ref. No.
D907
D951
Location
G-12
H-13
IC901
IC951
G-8
C-13
Ref. No.
LED901
LED902
LED903
LED904
Location
A-2
C-14
C-14
C-2
Ref. No.
LED905
LED906
LED910
LED911
Location
C-1
C-12
C-4
C-11
(Page 31)
32
32
R979
R951
R940
R955
R942
C952
D901
R941
R961
D905
D902
C956
D903
R958
R914
D904
R959
R962
H
R953
C953
R957
C955
R956
R954
R960
R968
R966
IC901
R908
R967
R969
R978
FMB5
R980
R982
R902
R903
R906
R907
R905
R904
R917
R918
R975
R909
G
R919
R916
R952
R910
R976
R977
R972
R920
F
CDX-MP40
3-14. SCHEMATIC DIAGRAM — RELAY, KEY SECTION (US, Canadian MODEL) —
R972
R967
R940
R974
R978
R976
R980
R951
R982
R941
LED910
LSW901(2/2)
LSW914(2/2)
LSW910(2/2)
LSW912(2/2)
LSW915(2/2)
LSW909(2/2)
LSW905(2/2)
LSW902(2/2)
LSW906(2/2)
LED904
IC951
C951
D951
R966
LED911
LED906
R952
LSW911(2/2)
R968
R969 R942
LSW916(2/2)
LSW908(2/2)
LED902
LSW903(2/2)
C954
C956
C955
LED905
R958
R962
R959
R960
R957
R953
R954
R955
R956
C953
C952
R943
LSW913(2/2)
LSW917(2/2)
LSW907(2/2)
LED903
LSW904(2/2)
LED901
IC901
R961
R973
R975
R979
R977
R981
R983
D905
S902
R901
LSW913(1/2) R912
S901
R902
LSW911(1/2)
S903
R903
LSW903(1/2)
R904
LSW901(1/2)
R932
R930
CN901
S931
D907
D901
D903
D902
D905
LED930
D904
D907
CNP903
CNP902
LED931
R931
D906
C973
LSW912(1/2)
LSW914(1/2)
LSW904(1/2)
C974
R913
R914
R915
LCD901
R905
LSW915(1/2) R917
LSW905(1/2)
R906
LSW906(1/2)
R907
LSW902(1/2)
R908
LSW907(1/2)
R909
LSW916(1/2) R918
(Page 30)
D904
D903
D902
D901
LSW917(1/2) R919
LSW910(1/2) R920
LSW909(1/2) R916
LSW908(1/2) R910
Note:
• Voltage is dc with respect to ground under no-signal
conditions.
no mark : FM
33
33
CDX-MP40
3-15. PRINTED WIRING BOARD — KEY SECTION (AEP, UK MODEL) — • Refer to page 20 for Circuit Boards Location.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
A
LED954
LSW907
S903
IC971
LSW906
LSW901
LSW919
LSW909
D
S911
LSW914
LSW922
LSW910
LSW920
LSW921
LSW918
LSW917
LSW915
LSW916
LSW908
E
R916
R915
R918
R914
D901
CN901
R927
R930
R979
R980
R978
C986
D902
R928
D981
C981
R985
R986
C982
R987
C983
C984
R988
R981
R929
FMB6
R960
R976
R902
R977
R975
I
• Semiconductor Location
Ref. No. Location
Ref. No.
D901
H-10
IC971
D902
H-11
D981
G-6
LED903
D983
H-6
LED911
LED933
IC901
G-8
Location
C-13
C-2
C-14
C-11
Ref. No.
LED934
LED951
LED952
LED953
LED954
Location
C-4
C-14
C-12
C-1
A-2
(Page 31)
34
C971
R971
IC901
C985
R989
R970
R961
J
R934
R901
R972
R919
R921
R917
FMB5
R982
R990
R983
R947
R946
D983
R962
R942
R941
R906 R907
R905
R903
R908
G
H
R910
R909
R920
34
R931
F
LED951
LED952
LED911
R950
R967
LED933
LED934
R951
R904
LED903
LED953
C
R936
LSW905
R966
LSW912
R913
R912
LSW904
B
R911
S902
R935
LSW913
CDX-MP40
3-16. SCHEMATIC DIAGRAM — RELAY, KEY SECTION (AEP, UK MODEL) —
R981
R982
R972
R983
IC971
LSW912(2/2)
LSW913(2/2)
LED933
LSW915(2/2)
LSW919(2/2)
LSW905(2/2)
LED903
C971
R930
R935
R950
LSW916(2/2)
R928
R931
LED954
D981
LSW920(2/2)
LED953
R951
R936
D983
R927
R990
C981
C986
LED952
LSW917(2/2)
LED911
R929
LSW921(2/2)
LSW906(2/2)
LSW914(2/2)
LSW918(2/2)
LED951
LED934
R934
LSW922(2/2)
R941
R946
R942
R947
LSW901(2/2)
R960
R989
LSW904(2/2)
R961
R966
R962
R967
C985
C983
C984
R979
R980
R978
LSW909(2/2)
LSW910(2/2)
LSW908(2/2)
IC901
R986
R987
R988
R985
C982
LSW907(2/2)
R970
R911
R912
LSW913(1/2)
S911
R902
R903
LSW901(1/2)
S931
CNP902
CN901
LSW914(1/2) LSW915(1/2)
R915
R916
R917
R918
R919
R920
R921
LSW916(1/2)
LSW917(1/2)
LSW918(1/2)
LSW919(1/2)
LSW920(1/2)
LSW921(1/2)
LSW922(1/2)
R907
R908
R909
R910
R971
S902
LSW908(1/2)
LSW909(1/2)
R904
R905
R906
LSW904(1/2)
LSW905(1/2)
LSW906(1/2)
LSW907(1/2)
LSW910(1/2)
S903
D902
D901
D903
D902
D905
LED930
D904
R930
D907
R931
D906
C973
CNP903
LED931
R914
LSW912(1/2)
R901
R932
R913
C974
(Page 30)
R975
R976
R977
D901
LCD901
Note:
• Voltage is dc with respect to ground under no-signal
conditions.
no mark : FM
35
35
CDX-MP40
3-17. IC BLOCK DIAGRAMS
7F DAC0
MD
SD
TD
FD
AGND
ATEST
TEST1
TEST0
DGND
TSTB
TSCK
TSI
TSO
PACK
DVDD
68
67
66
65
64
63
62
61
60
59
58
57
56
55
54
53
52
51
MICROCOMPUTER INTERFACE
COMPARATOR
CD-TEXT DECODER
D/A
IN1
5
IN2
6
ADDER
SVCRAM
42 RFCK
TIMING GENERATOR
ROM
DECODER
EFM
39 TSOI
CLV
PROCESSOR
FEO
TRACKING
REGISTER
FOCUS
REGISTER
TEO
AGND 96
OUTPUT PROCESSOR
A/D CONVERTER
TE2 94
TEC 95
DE-EMPHASIS CIRCUIT
OCTUPLED
OVERSAMPLING DIGITAL FILTER
COMPARATOR
PD 97
NOISE SHAVER
37 DGND
VO2– 11
36 TX
VO2+ 12
10k
35 HOLD/WDCK
34 LRCK
10k
LEVEL
SHIFT
32 SCKO
LEVEL
SHIFT
10k
10k
10k
10k
–
RST 2
RESET
SWITCH
13 RST
BATT 3
BATT
SWITCH
12 BUSON
LEVEL
SHIFT
LEVEL
SHIFT
–
10k
10k
18 VO3–
CLK 4
11 CLK-IN
VREF 5
10 B/U-C
DATA
6
I/O
9 DATA IN
17 VO3+
10k
10k
–
33 LRCKIN
VO1+ 14
10k
–
–
10k
VO1– 13
10k
10k
–
14 VCC
BUSON 1
19 GND
+
MIRR
MIRENV
21 MUTE
20 POWVCC
+
A3T
TEO 93
D/A
INTERFACE
CIRCUIT
RFENV
IC803 MM1175XFF
CH1-4
MUTE
VOL+ 10
+
FOK
TE- 92
+
POWVCC34
(CH3,CH4)
+
DIGITAL
AUDIO
INTERFACE
DEFECT
COMPARATOR
FEO 91
9
38 C16M
SWITCH
DEFECT
VOL–
+
41 LOCK
40 DVDD
FE- 90
8
22 OPOUT3
+
SVROM
F 86
REFOUT 89
POWVCC12
(CH1.CH2)
POWVCC
+
+
RF
AMP BLOCK
AVDD 88
7
+
–
MULTIPLIER
B 84
E 87
PREVCC
43 MIRR/WFCK
SVDRAM
TEOFS
D 85
44 PLCK
–
C 83
DIGITAL PLL
EFM DEMODULATOR
FEOFS
24 OPIN3+
23 OPIN3–
–
–
PREVCC
(PRE.LOADING)
45 DGND
A 82
25 OPOUT4
47 C1D2
46 C1D1
AGND 81
POWER
SAVE
16k
RF- 80
FD/TD/SD/MD
CONTROLLER
4
48 C2D1
+
AUTO GAIN
CONTROLLER
SUB-CODE PROCESSOR
16K
SRAM
MEMORY
PROCESSOR
PS
X3
+
EQ1 79
3
+
EFM
LDCONT
49 C2D2
27 OPIN4+
26 OPIN4–
–
16 VO4–
15 VO4+
–
EQ2 78
50 C2D3
LOADING PRE
FWD REV
–
RFO 77
ERROR
CORRECTION
PROCESSOR
EFM
2
+
AGCI 76
REV
16k
7C DAC1
69
16k
7D DAC2
70
5 VCC
4 OUT
IN B 1
IN A 2
GND 3
7.5k
7E DAC3
71
7.5k
AVDD
72
7.5k
EFM
73
28 BIAS
–
ASY
74
1
16k
C3T
75
FWD
IC12 TC7SH08FU-TE85R
7.5k
RFI
IC2 BA5810FP-E2
AGCO
IC1 µPD63711GC-8EU
GND 7
10k
10k
8 DATA OUT
31 SCKIN
30 DOUT
29 DIN
NOISE SHAVER
LD 98
28 FLAG
OUTPUT BUFFER OUTPUT BUFFER
27 EMPH
26 DVDD
16
17
18
19
20
21
22
23
24
25
RFOK
RST
A0
STB
SCK
SO
SI
XTALEN
DVDD
DAVDD
ROUT
DAGND
REGC
DAGND
LOUT
DAVDD
R+
R–
L–
L+
XVDD
XTAL
XTAL
XGND
MAD
PSWN
15
AFIN
14
20
19
18
17
16
15
14
13
12 11
PAUSE
DETECTOR
POWER SUPPLY
& RESET
MULTI
PATH
DETECTOR
57kHz
8th ORDER
BAND-PASS FILTER
CLOCKED
COMPARATOR
SIGNAL QUALITY
DECODER
4
5
CLOCK
RDS/RDBS
DEMODULATOR
RDS/RDBS
DECODER
4
CLOCK
INTERFACE
REGISTER
DATA
DATA
TEST
CONTROL
36
36
OSCILLATOR
& CLOCK
IIC BUS SLAVE
TRANSCEIVER
1 2
3
4
5
6
7
8
9
10
SCL
13
SDA
12
VDDA
11
VSSA
10
MPX
9
VREF
8
DAVN
7
VDDD
6
VSSD
5
OSCI
4
SCOUT
3
OSCO
2
IC601 SAA6588T/V2-518
CIN
1
DGND
OSC
TCON
SCF
LVIN
MICROCOMPUTER INTERFACE
MRO
MPTH
PN 99
AVDD 100
CDX-MP40
IC401 BD3802F (MAIN Board)
D-GND
28
SDA
27
SCL
26
MUTE
25
SEL
24
ADJ
23
VCC
22
OUTFR
21
OUTRR
20
OUTFL
19
OUTRL
18
DS32
17
DS22
16
DS12
15
VCC
FADER
(0~-58,
-∞dB)
2
I C BUS
LOGIC
VCO
ON
FADER
(0~-58,
-∞dB)
FADER
(0~-58,
-∞dB)
OFF
ON
EFFECT (OFF,6dB,
10dB,14dB)
FADER
(0~-58,
-∞dB)
OFF
EFFECT (OFF,6dB,
10dB,14dB)
TONE
PASS
TONE
PASS
BASS,TREBLE, MIDDLE
(-15dB~+15dB,1dB STEP)
BASS,TREBLE, MIDDLE
(-15dB~+15dB,1dB STEP)
VOLUME
(+23~-79dB,-∞dB
1dB STEP)
VOLUME
(+23~-79dB,-∞dB
1dB STEP)
INPUT GAIN
(0~15dB,1dB STEP)
INPUT GAIN
(0~15dB,1dB STEP)
MUTE
MUTE
INPUT SELECTOR
(4 STEREO INCLUDE 1 ISOLATION INPUT)
VCC/2
1
A-GND
2
FIL
3
BUSRCH
4
AN
5
BUSLCH
6
TURCH
7
TULCH
8
CDRCH
9
CDLCH
10
D1
11 12
13 14
D2 DS11 DS21 DS31
37
CDX-MP40
SECTION 4
EXPLODED VIEWS
NOTE:
• The mechanical parts with no reference
number in the exploded views are not supplied.
• Items marked “*” are not stocked since
they are seldom required for routine service.
Some delay should be anticipated
when ordering these items.
• -XX and -X mean standardized parts, so
they may have some difference from the
original one.
• Color Indication of Appearance Parts
Example :
KNOB, BALANCE (WHITE) ... (RED)
R
R
Parts Color Cabinet’s Color
• Accessories are given in the last of this
parts list.
• Abbreviation
CND: Canadian model
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
Les composants identifiés par une
marque 0 sont critiques pour
la sécurité.
Ne les remplacer que par une piéce
portant le numéro spécifié.
4-1. CHASSIS SECTION
9
10
MG-393MC-121
#1
15
#1
#3
#3
11
#5
not
supplied
not supplied
#4
#3
13
#3
14
#3
not
supplied
12
TUX501
4
not supplied
(RELAY board)
F901
5
not supplied
1
6
2
8
11
#1
7
#2
#1
#2
#2
3
#1
not supplied
not supplied
Ref. No.
Part No.
Description
1
2
3
4
* 5
X-3382-626-1
3-246-030-01
1-792-173-11
X-3376-686-4
X-3376-689-2
PANEL ASSY (CD), SUB
BUTTON (EJECT)
CABLE, FLAT (FFC) 12P
GEAR ASSY
BRACKET (GEAR) ASSY
6
7
8
9
9
3-030-909-03
3-713-786-51
X-3376-687-2
1-776-207-82
1-776-527-61
DAMPER, OIL
SCREW +P 2X3
LOCK ASSY
CORD (WITH CONNECTOR) (POWER) (US,CND)
CORD (WITH CONNECTOR) (ISO) (POWER)
(AEP,UK)
10
11
3-246-007-01 BRACKET (CD)
3-922-535-11 SCREW (+BTT)
38
Remark
Ref. No.
Part No.
Description
12
12
13
* 14
15
A-3274-739-A
A-3274-742-A
3-041-261-11
3-019-565-01
3-223-913-11
MAIN BOARD, COMPLETE (US,CND)
MAIN BOARD, COMPLETE (AEP,UK)
BRACKET (TR)
BRACKET (IC)
LABEL (OP CAUTION) (AEP,UK)
F901
TUX501
#1
#2
#3
1-532-877-11
A-3220-887-A
7-685-792-09
7-621-772-20
7-685-793-09
FUSE (BLADE TYPE) (AUTO FUSE) 10A
TUNER UNIT (TUX-030)
SCREW +PTT 2.6X6 (S)
SCREW +B 2X5
SCREW +PTT 2.6X8 (S)
#4
#5
7-685-795-09 SCREW +PTT 2.6X12 (S)
7-685-134-19 SCREW +P 2.6X8 TYPE2 NON-SLIT
Remark
CDX-MP40
4-2. FRONT PANEL SECTION
not supplied
(DISPLAY board (US, CND))
(KEY board (AEP, UK))
#6
not supplied
#6
not supplied
57
LCD901
56
55
not supplied
not supplied
54
not supplied
not supplied
not
supplied
52
53
not
supplied
51
Ref. No.
Part No.
Description
51
51
52
52
53
A-3337-163-A
A-3337-442-A
X-3382-827-1
X-3383-151-1
3-246-534-01
OVERALL ASSY, FRONT PANEL (AEP,UK)
PANEL COMPLETE ASSY, FRONT (US,CND)
PANEL (S) ASSY, FRONT (AEP,UK)
PANEL (S) ASSY, FRONT (US,CND)
SPRING (RELEASE) (US,CND)
Remark
53
54
54
55
55
3-246-778-01
X-3383-105-1
X-3383-169-1
1-694-976-11
1-694-989-11
SPRING (OPEN) (AEP,UK)
BUTTON ASSY (S) (AEP,UK)
BUTTON ASSY (S) (US,CND)
CONDUCTIVE BOARD, CONNECTION (AEP,UK)
CONDUCTIVE BOARD, CONNECTION (US,CND)
Ref. No.
Part No.
Description
56
56
57
57
X-3382-625-1
X-3382-702-1
X-3378-390-3
X-3378-490-2
#6
7-685-106-19 SCREW +P 2X10 TYPE2 NON-SLIT
Remark
PANEL ASSY, FRONT BACK (US,CND)
PANEL ASSY, FRONT BACK (AEP,UK)
CASE ASSY (for FRONT PANEL) (US,CND)
CASE (PANEL) ASSY (for FRONT PANEL)
(AEP,UK)
LCD901 1-805-084-11 DISPLAY PANEL, LIQUID CRYSTAL
39
CDX-MP40
4-3. CD MECHANISM SECTION (1)
(MG-393MC-121)
102
#7
#7
104
103
107
101
109
116
#8
117
114
106
115
114
105
105
113
110
108
M903
#9
112
111
#7
#8
Ref. No.
Part No.
Description
Part No.
Description
101
102
103
104
105
A-3274-253-A
3-040-039-03
3-040-038-01
3-040-050-01
3-040-022-01
DISC IN SW BOARD, COMPLETE
CHASSIS (T)
SPRING (LR), TENSION
LEVER (L)
RETAINER (ROLLER), SHAFT
112
113
114
115
116
3-221-779-02
3-040-034-01
3-040-042-01
3-043-880-01
3-044-206-11
BRACKET (MOTOR)
SPRING (RA), TENSION
WASHER
RING (RA), RETAINING
SCREW, SPECIAL
106
107
108
109
110
3-040-044-01
3-040-067-01
A-3301-980-A
3-040-037-01
3-040-040-03
ROLLER (S)
LEVER (R)
SHAFT ROLLER ASSY
GUIDE (DISC)
ARM (ROLLER)
117
M903
#7
#8
#9
1-685-337-11
A-3315-039-A
7-627-553-37
7-628-253-00
7-627-553-17
LOAD SW BOARD
MOTOR SUB ASSY, LO (LOADING)
SCREW, PRECISION +P 2X3 TYPE 3
SCREW, SPECIAL
SCREW, PRECISION +P 2X2 TYPE 3
111
A-3274-698-A SERVO BOARD, COMPLETE
40
Remark
Ref. No.
Remark
CDX-MP40
4-4. CD MECHANISM SECTION (2)
(MG-393MC-121)
154
151
156
157
157
158
164
160
not supplied
162
153
155
163
161
159
152
152
152
Ref. No.
Part No.
Description
151
152
153
154
155
3-040-025-02
3-040-031-01
3-040-056-01
3-040-024-01
3-040-054-01
ARM, CHUCKING
DAMPER (T)
LEVER (D)
RETAINER (DISC)
WHEEL (LW), WORM
156
157
3-040-026-01 SPRING (CH), TENSION
3-040-032-01 SPRING (FL), COMPRESSION
Remark
Ref. No.
Part No.
Description
158
159
160
161
162
3-040-033-01
A-3307-422-A
3-040-059-01
3-040-057-01
3-040-058-01
SPRING (KF1), TENSION
CHASSIS (M) COMPLETE ASSY
SPRING (TR), TENSION
LEVER (LOCK)
GEAR (MDL)
163
164
3-040-052-01 WHEEL (U), WORM
3-040-051-02 LEVER (TR)
Remark
41
CDX-MP40
4-5. CD MECHANISM SECTION (3)
(MG-393MC-121)
201
not supplied
207
202
208
M902
203
209
#10
#7
211
204
205
206
210
209
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
Ref. No.
Part No.
Description
201
202
203
204
205
A-3337-193-A
3-040-029-01
3-040-045-01
3-040-194-01
A-3301-983-A
FLOATING BLOCK ASSY
SPRING (SL), TORSION
BASE (DRIVING)
GEAR (MIDWAY)
SHAFT (FEED) ASSY
206
207
3-040-030-01 SPRING (FEED), PLATE
1-823-951-11 CABLE, FLEXIBLE FLAT (16 CORE)
42
Remark
Les composants identifiés par une
marque 0 sont critiques pour
la sécurité.
Ne les remplacer que par une piéce
portant le numéro spécifié.
Ref. No.
Part No.
Description
208
209
0 210
211
M902
A-3274-254-A
3-909-607-01
8-820-165-06
1-676-707-11
A-3301-985-A
LIMIT SW BOARD, COMPLETE
SCREW
OPTICAL PICK-UP KSS-721A/C-RP
PICK-UP FLEXIBLE BOARD
MOTOR ASSY, SLED (SLED)
#7
#10
7-627-553-37 SCREW, PRECISION +P 2X3 TYPE 3
7-627-850-28 SCREW, PRECISION +P 1.4X3
Remark
CDX-MP40
SECTION 5
ELECTRICAL PARTS LIST
NOTE:
• Due to standardization, replacements in
the parts list may be different from the
parts specified in the diagrams or the
components used on the set.
• -XX and -X mean standardized parts, so
they may have some difference from the
original one.
• RESISTORS
All resistors are in ohms.
METAL:Metal-film resistor.
METAL OXIDE: Metal oxide-film resistor.
F:nonflammable
• Abbreviation
CND: Canadian model
Ref. No.
Part No.
• Items marked “*” are not stocked since
they are seldom required for routine service.
Some delay should be anticipated
when ordering these items.
• SEMICONDUCTORS
In each case, u : µ, for example:
uA.. : µA.. uPA.. : µPA..
uPB.. : µPB.. uPC.. : µPC.. uPD.. : µPD..
• CAPACITORS
uF : µF
• COILS
uH : µH
DISC IN SW
DISPLAY
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
Les composants identifiés par une
marque 0 sont critiques pour
la sécurité.
Ne les remplacer que par une piéce
portant le numéro spécifié.
When indicating parts by reference
number, please include the board.
Description
Remark
A-3274-253-A DISC IN SW BOARD, COMPLETE
**************************
*************************************************************
DISPLAY BOARD (US,CND)
**************
1-694-989-11 CONDUCTIVE BOARD, CONNECTION (US,CND)
Ref. No.
LED903
LED904
LED905
LED906
LED910
Part No.
Description
8-719-053-09
8-719-053-09
8-719-053-09
8-719-053-09
6-500-459-01
LED
LED
LED
LED
LED
Remark
SML-310VT-T86 (EQ3) (US,CND)
SML-310VT-T86 (DSO) (US,CND)
SML-310VT-T86 (DSO) (US,CND)
SML-310VT-T86 (SEEK) (US,CND)
NSCW505T-ARS (LCD BACK LIGHT)
(US,CND)
LED911 6-500-459-01 LED NSCW505T-ARS (LCD BACK LIGHT)
(US,CND)
< CAPACITOR >
< SWITCH >
C951
1-164-227-11 CERAMIC CHIP
0.022uF
10%
C952
1-125-891-11 CERAMIC CHIP
0.47uF
10%
C953
1-162-927-11 CERAMIC CHIP
100PF
5%
C954
1-164-227-11 CERAMIC CHIP
0.022uF
10%
C955
1-107-826-11 CERAMIC CHIP
0.1uF
10%
C956
1-107-826-11 CERAMIC CHIP
0.1uF
10%
25V
(US,CND)
10V
(US,CND)
50V
(US,CND)
25V
(US,CND)
16V
(US,CND)
16V
(US,CND)
< CONNECTOR >
CN901
1-817-158-11 PLUG, CONNECTOR 14P (US,CND)
< DIODE >
D901
D902
D903
D904
D905
8-719-083-66
8-719-978-33
8-719-978-33
8-719-978-33
8-719-988-61
DIODE
DIODE
DIODE
DIODE
DIODE
UDZS-TE-17-18B (US,CND)
DTZ-TT11-6.8B (US,CND)
DTZ-TT11-6.8B (US,CND)
DTZ-TT11-6.8B (US,CND)
1SS355TE-17 (US,CND)
D907
D951
8-719-978-33 DIODE DTZ-TT11-6.8B (US,CND)
8-719-069-54 DIODE UDZS-TE-17-5.1B (US,CND)
< IC >
IC901
IC951
8-759-826-21 IC LC75874W (US,CND)
8-749-017-35 IC KSM-401N (US,CND)
< LIQUID CRYSTAL DISPLAY >
LSW901 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (OFF)
(US,CND)
LSW902 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (MODE)
(US,CND)
LSW903 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (SEL)
(US,CND)
LSW904 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (VOLUME +)
(US,CND)
LSW905 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (VOLUME –)
(US,CND)
LSW906 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (ATT)
(US,CND)
LSW907 1-771-883-31 SWITCH, TACTILE (WITH LED) (SENS)
(US,CND)
LSW908 1-771-883-31 SWITCH, TACTILE (WITH LED) (1/DISC –)
(US,CND)
LSW909 1-771-883-31 SWITCH, TACTILE (WITH LED) (2/DISC +)
(US,CND)
LSW910 1-771-883-31 SWITCH, TACTILE (WITH LED) (3/REP)
(US,CND)
LSW911 1-771-476-11 SWITCH, KEYBOARD (WITH LED)
(+ > M SEEK) (US,CND)
LSW912 1-771-476-11 SWITCH, KEYBOARD (WITH LED)
(SEEK m . –) (US,CND)
LSW913 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (DSPL)
(US,CND)
LSW914 1-771-883-31 SWITCH, TACTILE (WITH LED) (BTM)
(US,CND)
LSW915 1-771-883-31 SWITCH, TACTILE (WITH LED) (6) (US,CND)
LSW916 1-771-883-31 SWITCH, TACTILE (WITH LED) (5) (US,CND)
LSW917 1-771-883-31 SWITCH, TACTILE (WITH LED) (4/SHUF)
(US,CND)
LCD901 1-805-084-11 DISPLAY PANEL, LIQUID CRYSTAL (US,CND)
< RESISTOR >
< DIODE >
R901
LED901 8-719-053-09 LED SML-310VT-T86 (SOURCE) (US,CND)
LED902 8-719-053-09 LED SML-310VT-T86 (EQ3) (US,CND)
1-216-819-11 METAL CHIP
680
5%
1/10W
(US,CND)
43
CDX-MP40
DISPLAY
Ref. No.
Part No.
KEY
Description
Remark
R902
1-216-819-11 METAL CHIP
680
5%
R903
1-216-819-11 METAL CHIP
680
5%
R904
1-216-821-11 METAL CHIP
1K
5%
R905
1-216-823-11 METAL CHIP
1.5K
5%
R906
1-216-823-11 METAL CHIP
1.5K
5%
R907
1-216-825-11 METAL CHIP
2.2K
5%
R908
1-216-827-11 METAL CHIP
3.3K
5%
R909
1-216-834-11 METAL CHIP
12K
5%
R910
1-216-832-11 METAL CHIP
8.2K
5%
R912
1-216-819-11 METAL CHIP
680
5%
R913
1-216-819-11 METAL CHIP
680
5%
R914
1-216-819-11 METAL CHIP
680
5%
R915
1-216-826-11 METAL CHIP
2.7K
5%
R916
1-218-867-11 METAL CHIP
6.8K
5%
R917
1-216-823-11 METAL CHIP
1.5K
5%
R918
1-216-825-11 METAL CHIP
2.2K
5%
R919
1-216-827-11 METAL CHIP
3.3K
5%
R920
1-216-829-11 METAL CHIP
4.7K
5%
R940
1-216-815-11 METAL CHIP
330
5%
R941
1-216-817-11 METAL CHIP
470
5%
R942
1-216-815-11 METAL CHIP
330
5%
R943
1-216-817-11 METAL CHIP
470
5%
R951
1-216-815-11 METAL CHIP
330
5%
R952
1-216-825-11 METAL CHIP
2.2K
5%
R953
1-216-821-11 METAL CHIP
1K
5%
R954
1-216-821-11 METAL CHIP
1K
5%
R955
1-216-821-11 METAL CHIP
1K
5%
R956
1-216-821-11 METAL CHIP
1K
5%
R957
1-216-850-11 METAL CHIP
270K
5%
R958
1-216-809-11 METAL CHIP
100
5%
R959
1-216-821-11 METAL CHIP
1K
5%
44
Ref. No.
Part No.
Description
Remark
1/10W
(US,CND)
1/10W
(US,CND)
1/10W
(US,CND)
1/10W
(US,CND)
1/10W
(US,CND)
R960
1-216-821-11 METAL CHIP
1K
5%
R961
1-216-857-11 METAL CHIP
1M
5%
R962
1-216-821-11 METAL CHIP
1K
5%
R966
1-216-815-11 METAL CHIP
330
5%
R967
1-216-817-11 METAL CHIP
470
5%
1/10W
(US,CND)
1/10W
(US,CND)
1/10W
(US,CND)
1/10W
(US,CND)
1/10W
(US,CND)
R968
1-216-815-11 METAL CHIP
330
5%
R969
1-216-817-11 METAL CHIP
470
5%
R972
1-216-809-11 METAL CHIP
100
5%
R973
1-216-809-11 METAL CHIP
100
5%
R974
1-216-809-11 METAL CHIP
100
5%
1/10W
(US,CND)
1/10W
(US,CND)
1/10W
(US,CND)
1/10W
(US,CND)
1/10W
(US,CND)
R975
1-216-809-11 METAL CHIP
100
5%
R976
1-216-809-11 METAL CHIP
100
5%
R977
1-216-809-11 METAL CHIP
100
5%
R978
1-216-811-11 METAL CHIP
150
5%
R979
1-216-811-11 METAL CHIP
150
5%
1/10W
(US,CND)
1/10W
(US,CND)
1/10W
(US,CND)
1/10W
(US,CND)
1/10W
(US,CND)
R980
1-216-809-11 METAL CHIP
100
5%
R981
1-216-809-11 METAL CHIP
100
5%
R982
1-216-809-11 METAL CHIP
100
5%
R983
1-216-809-11 METAL CHIP
100
5%
1/10W
(US,CND)
1/10W
(US,CND)
1/10W
(US,CND)
1/10W
(US,CND)
1/10W
(US,CND)
S901
1/10W
(US,CND)
1/10W
(US,CND)
1/10W
(US,CND)
1/10W
(US,CND)
1/10W
(US,CND)
1/10W
(US,CND)
1/10W
(US,CND)
1/10W
(US,CND)
1/10W
(US,CND)
1/10W
(US,CND)
1/10W
(US,CND)
1/10W
(US,CND)
1/10W
(US,CND)
1/10W
(US,CND)
1/10W
(US,CND)
1/10W
(US,CND)
1/10W
(US,CND)
1/10W
(US,CND)
1/10W
(US,CND)
1/10W
(US,CND)
1/10W
(US,CND)
1/10W
(US,CND)
1/10W
(US,CND)
1/10W
(US,CND)
1/10W
(US,CND)
< SWITCH >
1-771-884-31 SWITCH, TACTILE (WITH LED) (SOURCE)
(US,CND)
S902
1-771-884-31 SWITCH, TACTILE (WITH LED) (EQ3)
(US,CND)
S903
1-771-884-31 SWITCH, TACTILE (WITH LED) (DSO)
(US,CND)
**************************************************************
KEY BOARD (AEP,UK)
**********
1-694-976-11 CONDUCTIVE BOARD, CONNECTION (AEP,UK)
< CAPACITOR >
C971
1-107-826-11 CERAMIC CHIP
0.1uF
10%
C981
1-164-227-11 CERAMIC CHIP
0.022uF
10%
C982
1-164-227-11 CERAMIC CHIP
0.022uF
10%
C983
1-107-826-11 CERAMIC CHIP
0.1uF
10%
C984
1-107-826-11 CERAMIC CHIP
0.1uF
10%
16V
(AEP,UK)
25V
(AEP,UK)
25V
(AEP,UK)
16V
(AEP,UK)
16V
(AEP,UK)
CDX-MP40
KEY
Ref. No.
Part No.
Description
Remark
C985
1-162-964-11 CERAMIC CHIP
0.001uF
10%
C986
1-127-715-11 CERAMIC CHIP
0.22uF
10%
50V
(AEP,UK)
16V
(AEP,UK)
< CONNECTOR >
CN901
1-817-158-21 PLUG, CONNECTOR 14P (AEP,UK)
< DIODE >
D901
D902
D981
D983
8-719-085-72
8-719-083-66
8-719-069-54
8-719-404-50
DIODE
DIODE
DIODE
DIODE
UMZ6.8ENTR (AEP,UK)
UDZS-TE-17-18B (AEP,UK)
UDZS-TE-17-5.1B (AEP,UK)
MA111-TX (AEP,UK)
Ref. No.
Part No.
Description
Remark
LSW918 1-771-883-31 SWITCH, TACTILE (WITH LED) (5/ALBUM –)
(AEP,UK)
LSW919 1-771-883-31 SWITCH, TACTILE (WITH LED) (4/SHUF)
(AEP,UK)
LSW920 1-771-883-31 SWITCH, TACTILE (WITH LED) (3/REP)
(AEP,UK)
LSW921 1-771-883-31 SWITCH, TACTILE (WITH LED) (2/DISC +)
(AEP,UK)
LSW922 1-771-883-31 SWITCH, TACTILE (WITH LED) (1/DISC –)
(AEP,UK)
< RESISTOR >
R901
1-216-819-11 METAL CHIP
680
5%
R902
1-216-819-11 METAL CHIP
680
5%
R903
1-216-819-11 METAL CHIP
680
5%
R904
1-216-821-11 METAL CHIP
1K
5%
R905
1-216-823-11 METAL CHIP
1.5K
5%
R906
1-216-823-11 METAL CHIP
1.5K
5%
R907
1-216-825-11 METAL CHIP
2.2K
5%
R908
1-216-827-11 METAL CHIP
3.3K
5%
R909
1-216-829-11 METAL CHIP
4.7K
5%
R910
1-218-867-11 METAL CHIP
6.8K
5%
R911
1-216-819-11 METAL CHIP
680
5%
R912
1-216-819-11 METAL CHIP
680
5%
R913
1-216-819-11 METAL CHIP
680
5%
LSW901 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (OFF)
(AEP,UK)
LSW904 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (SEL)
(AEP,UK)
LSW905 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (VOLUME +)
(AEP,UK)
LSW906 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (VOLUME –)
(AEP,UK)
LSW907 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (ATT)
(AEP,UK)
R914
1-216-821-11 METAL CHIP
1K
5%
R915
1-216-823-11 METAL CHIP
1.5K
5%
R916
1-216-823-11 METAL CHIP
1.5K
5%
R917
1-216-825-11 METAL CHIP
2.2K
5%
R918
1-216-827-11 METAL CHIP
3.3K
5%
LSW908 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (MODE)
(AEP,UK)
LSW909 1-771-883-31 SWITCH, TACTILE (WITH LED) (AF) (AEP,UK)
LSW910 1-771-883-31 SWITCH, TACTILE (WITH LED) (SENS/BTM)
(AEP,UK)
LSW912 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (DSPL)
(AEP,UK)
LSW913 1-771-476-11 SWITCH, KEYBOARD (WITH LED)
(+ > M SEEK) (AEP,UK)
R919
1-216-829-11 METAL CHIP
4.7K
5%
R920
1-218-867-11 METAL CHIP
6.8K
5%
R921
1-216-833-11 METAL CHIP
10K
5%
R927
1-216-025-11 RES-CHIP
100
5%
R928
1-216-021-00 METAL CHIP
68
5%
R929
1-216-033-00 METAL CHIP
220
5%
R930
1-216-017-11 RES-CHIP
47
5%
< IC >
IC901
IC971
8-759-826-21 IC LC75874W (AEP,UK)
6-600-163-01 IC RS-770 (AEP,UK)
< LIQUID CRYSTAL DISPLAY >
1/10W
(AEP,UK)
1/10W
(AEP,UK)
1/10W
(AEP,UK)
1/10W
(AEP,UK)
1/10W
(AEP,UK)
LCD901 1-805-084-11 DISPLAY PANEL, LIQUID CRYSTAL (AEP,UK)
< DIODE >
LED903 6-500-450-01 LED CL-195SR-CD-T (DSO) (AEP,UK)
LED911 6-500-450-01 LED CL-195SR-CD-T (EQ3) (AEP,UK)
LED933 6-500-459-01 LED NSCW505T-ARS (LCD BACK LIGHT)
(AEP,UK)
LED934 6-500-459-01 LED NSCW505T-ARS (LCD BACK LIGHT)
(AEP,UK)
LED951 6-500-450-01 LED CL-195SR-CD-T (EQ3) (AEP,UK)
LED952 6-500-450-01 LED CL-195SR-CD-T (SEEK) (AEP,UK)
LED953 6-500-450-01 LED CL-195SR-CD-T (DSO) (AEP,UK)
LED954 6-500-450-01 LED CL-195SR-CD-T (SOURCE) (AEP,UK)
< SWITCH >
LSW914 1-771-476-11 SWITCH, KEYBOARD (WITH LED)
(SEEK m . –) (AEP,UK)
LSW915 1-771-883-31 SWITCH, TACTILE (WITH LED) (TA) (AEP,UK)
LSW916 1-771-883-31 SWITCH, TACTILE (WITH LED) (PTY/LIST)
(AEP,UK)
LSW917 1-771-883-31 SWITCH, TACTILE (WITH LED) (6/ALBUM +)
(AEP,UK)
1/10W
(AEP,UK)
1/10W
(AEP,UK)
1/10W
(AEP,UK)
1/10W
(AEP,UK)
1/10W
(AEP,UK)
1/10W
(AEP,UK)
1/10W
(AEP,UK)
1/10W
(AEP,UK)
1/10W
(AEP,UK)
1/10W
(AEP,UK)
1/10W
(AEP,UK)
1/10W
(AEP,UK)
1/10W
(AEP,UK)
1/10W
(AEP,UK)
1/10W
(AEP,UK)
1/10W
(AEP,UK)
1/10W
(AEP,UK)
1/10W
(AEP,UK)
1/10W
(AEP,UK)
1/10W
(AEP,UK)
45
CDX-MP40
KEY
Ref. No.
LIMIT SW
Part No.
LOAD SW
Description
Remark
R931
1-216-041-00 METAL CHIP
470
5%
R934
1-216-017-11 RES-CHIP
47
5%
R935
1-216-025-11 RES-CHIP
100
5%
R936
1-216-021-00 METAL CHIP
68
5%
R941
1-216-025-11 RES-CHIP
100
5%
R942
1-216-021-00 METAL CHIP
68
5%
R946
1-216-025-11 RES-CHIP
100
5%
R947
1-216-021-00 METAL CHIP
68
5%
R950
1-216-025-11 RES-CHIP
100
5%
R951
1-216-021-00 METAL CHIP
68
5%
R960
1-216-025-11 RES-CHIP
100
5%
R961
1-216-025-11 RES-CHIP
100
5%
R962
1-216-029-00 METAL CHIP
150
5%
R966
1-216-025-11 RES-CHIP
100
5%
R967
1-216-037-00 METAL CHIP
330
5%
R970
1-216-864-11 METAL CHIP
0
5%
R971
1-216-821-11 METAL CHIP
1K
5%
R972
1-216-809-11 METAL CHIP
100
5%
R975
1-216-817-11 METAL CHIP
470
5%
R976
1-216-817-11 METAL CHIP
470
5%
R977
1-216-817-11 METAL CHIP
470
5%
R978
1-216-817-11 METAL CHIP
470
5%
R979
1-216-817-11 METAL CHIP
470
5%
R980
1-216-817-11 METAL CHIP
470
5%
R981
1-216-811-11 METAL CHIP
150
5%
R982
1-216-811-11 METAL CHIP
150
5%
R983
1-216-811-11 METAL CHIP
150
5%
R985
1-216-864-11 METAL CHIP
0
5%
R986
1-216-821-11 METAL CHIP
1K
5%
R987
1-216-821-11 METAL CHIP
1K
5%
R988
1-216-821-11 METAL CHIP
1K
5%
46
MAIN
1/10W
(AEP,UK)
1/10W
(AEP,UK)
1/10W
(AEP,UK)
1/10W
(AEP,UK)
1/10W
(AEP,UK)
1/10W
(AEP,UK)
1/10W
(AEP,UK)
1/10W
(AEP,UK)
1/10W
(AEP,UK)
1/10W
(AEP,UK)
1/10W
(AEP,UK)
1/10W
(AEP,UK)
1/10W
(AEP,UK)
1/10W
(AEP,UK)
1/10W
(AEP,UK)
1/10W
(AEP,UK)
1/10W
(AEP,UK)
1/10W
(AEP,UK)
1/10W
(AEP,UK)
1/10W
(AEP,UK)
1/10W
(AEP,UK)
1/10W
(AEP,UK)
1/10W
(AEP,UK)
1/10W
(AEP,UK)
1/10W
(AEP,UK)
1/10W
(AEP,UK)
1/10W
(AEP,UK)
1/10W
(AEP,UK)
1/10W
(AEP,UK)
1/10W
(AEP,UK)
1/10W
(AEP,UK)
Ref. No.
Part No.
Description
Remark
R989
1-216-840-11 METAL CHIP
39K
5%
R990
1-216-857-11 METAL CHIP
1M
5%
1/10W
(AEP,UK)
1/10W
(AEP,UK)
< SWITCH >
S902
1-771-884-31 SWITCH, TACTILE (WITH LED) (SOURCE)
(AEP,UK)
S903
1-771-884-31 SWITCH, TACTILE (WITH LED) (DSO)
(AEP,UK)
S911
1-771-884-31 SWITCH, TACTILE (WITH LED) (EQ3)
(AEP,UK)
*************************************************************
A-3274-254-A LIMIT SW BOARD, COMPLETE
*************************
< CONNECTOR >
CN13
1-816-275-21 CONNECTOR, FFC/FPC 6P
*************************************************************
1-685-337-11 LOAD SW BOARD
***************
*************************************************************
A-3274-739-A MAIN BOARD, COMPLETE (US,CND)
A-3274-742-A MAIN BOARD, COMPLETE (AEP,UK)
*********************
3-019-565-01
3-041-261-11
7-685-134-19
7-685-793-09
7-685-795-09
*
BRACKET (IC)
BRACKET (TR)
SCREW +P 2.6X8 TYPE2 NON-SLIT
SCREW +PTT 2.6X8 (S)
SCREW +PTT 2.6X12 (S)
< CAPACITOR >
C101
C106
C109
C201
C202
1-136-154-00
1-164-156-11
1-162-965-11
1-136-154-00
1-162-965-11
FILM
CERAMIC CHIP
CERAMIC CHIP
FILM
CERAMIC CHIP
0.012uF
0.1uF
0.0015uF
0.012uF
0.0015uF
5%
10%
5%
10%
50V
25V
50V
50V
50V
C203
C204
C205
C206
C207
1-162-964-11
1-162-964-11
1-162-964-11
1-162-964-11
1-164-160-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.001uF
0.001uF
0.001uF
0.001uF
20PF
10%
10%
10%
10%
5%
50V
50V
50V
50V
50V
C208
C209
C210
C211
C212
1-126-160-11
1-126-160-11
1-115-467-11
1-115-467-11
1-126-160-11
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT
1uF
1uF
0.22uF
0.22uF
1uF
20%
20%
10%
10%
20%
50V
50V
10V
10V
50V
C213
C215
C401
C402
C403
1-126-160-11
1-104-946-11
1-128-428-11
1-128-428-11
1-128-428-11
ELECT
ELECT
ELECT
ELECT
ELECT
1uF
10uF
10uF
10uF
10uF
20%
20%
20%
20%
20%
50V
35V
35V
35V
35V
C404
C405
C406
C407
C408
1-128-428-11
1-125-891-11
1-125-891-11
1-125-891-11
1-125-891-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
10uF
0.47uF
0.47uF
0.47uF
0.47uF
20%
10%
10%
10%
10%
35V
10V
10V
10V
10V
CDX-MP40
MAIN
Ref. No.
Part No.
Description
Part No.
Description
C409
C411
C412
C413
C415
1-164-227-11
1-124-233-11
1-128-428-11
1-136-177-00
1-107-826-11
CERAMIC CHIP
ELECT
ELECT
MYLAR
CERAMIC CHIP
0.022uF
10uF
10uF
1uF
0.1uF
10%
20%
20%
5%
10%
25V
16V
35V
50V
16V
Remark
C808
C809
C810
C811
C812
1-162-918-11
1-164-160-11
1-165-176-11
1-107-826-11
1-164-156-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
C416
C417
C418
C419
C420
1-162-927-11
1-162-927-11
1-162-927-11
1-162-927-11
1-162-927-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100PF
100PF
100PF
100PF
100PF
5%
5%
5%
5%
5%
50V
50V
50V
50V
50V
C813
C421
C423
C424
C425
C426
1-162-927-11
1-126-160-11
1-162-927-11
1-162-927-11
1-162-927-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100PF
1uF
100PF
100PF
100PF
5%
20%
5%
5%
5%
50V
50V
50V
50V
50V
C427
C428
C429
C503
1-162-927-11
1-162-964-11
1-162-964-11
1-124-259-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
100PF
0.001uF
0.001uF
4.7uF
5%
10%
10%
20%
C505
1-162-964-11 CERAMIC CHIP
0.001uF
10%
50V
50V
50V
16V
(AEP,UK)
50V
C506
C507
C615
1-162-964-11 CERAMIC CHIP
1-124-589-11 ELECT
1-162-964-11 CERAMIC CHIP
0.001uF
47uF
0.001uF
10%
20%
10%
C616
1-107-826-11 CERAMIC CHIP
0.1uF
10%
C617
1-162-916-11 CERAMIC CHIP
12PF
5%
C618
1-162-916-11 CERAMIC CHIP
12PF
5%
C621
1-164-360-11 CERAMIC CHIP
0.1uF
C622
1-162-959-11 CERAMIC CHIP
330PF
5%
C623
1-125-838-11 CERAMIC CHIP
2.2uF
10%
C624
1-164-739-11 CERAMIC CHIP
560PF
5%
C629
C701
C702
C703
C704
1-162-970-11
1-124-589-11
1-162-970-11
1-162-964-11
1-164-160-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
47uF
0.01uF
0.001uF
20PF
10%
20%
10%
10%
5%
25V
16V
25V
50V
50V
C705
C712
C713
C714
C715
1-164-160-11
1-124-584-00
1-124-584-00
1-124-584-00
1-128-057-11
CERAMIC CHIP
ELECT
ELECT
ELECT
ELECT
20PF
100uF
100uF
100uF
330uF
5%
20%
20%
20%
20%
50V
10V
10V
10V
6.3V
C716
C717
C718
C719
C802
1-164-156-11
1-162-970-11
1-125-837-11
1-162-964-11
1-162-927-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.01uF
1uF
0.001uF
100PF
10%
10%
10%
5%
25V
25V
6.3V
50V
50V
C803
C804
C805
C806
C807
1-162-970-11
1-126-940-11
1-162-970-11
1-128-647-11
1-164-156-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
DOUBLE LAYERS
CERAMIC CHIP
0.01uF
330uF
0.01uF
0.1F
0.1uF
10%
20%
10%
50V
16V
50V
(AEP,UK)
16V
(AEP,UK)
50V
(AEP,UK)
50V
(AEP,UK)
16V
(AEP,UK)
50V
(AEP,UK)
6.3V
(AEP,UK)
50V
(AEP,UK)
25V
16V
25V
5.5V
25V
Ref. No.
Remark
18PF
20PF
0.047uF
0.1uF
0.1uF
5%
5%
10%
10%
1-162-927-11 CERAMIC CHIP
100PF
5%
C813
1-216-864-11 METAL CHIP
0
5%
C814
C815
C816
1-164-160-11 CERAMIC CHIP
1-164-156-11 CERAMIC CHIP
1-109-982-11 CERAMIC CHIP
20PF
0.1uF
1uF
5%
C817
C818
C821
C822
C823
1-124-589-11
1-125-837-11
1-164-160-11
1-164-160-11
1-164-160-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
47uF
1uF
20PF
20PF
20PF
20%
10%
5%
5%
5%
10V
6.3V
50V
50V
50V
C825
C826
C827
C901
C902
1-107-826-11
1-162-964-11
1-162-964-11
1-135-473-21
1-115-156-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
0.1uF
0.001uF
0.001uF
3300uF
1uF
10%
10%
10%
20%
16V
50V
50V
16V
10V
(AEP,UK)
C905
1-115-156-11 CERAMIC CHIP
1uF
C907
C909
C910
C916
1-125-972-61
1-126-160-11
1-126-154-11
1-125-837-11
ELECT
ELECT
ELECT
CERAMIC CHIP
100uF
1uF
47uF
1uF
20%
20%
20%
10%
10V
(AEP,UK)
16V
50V
6.3V
6.3V
C917
C918
C920
C922
1-124-584-00
1-107-826-11
1-107-826-11
1-162-927-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100uF
0.1uF
0.1uF
100PF
20%
10%
10%
5%
10V
16V
16V
50V
10%
50V
50V
16V
16V
25V
50V
(AEP,UK)
1/10W
(US,CND)
50V
25V
10V
< CONNECTOR >
CNJ801
CNP701
CNP802
CNP901
1-580-907-31
1-815-260-11
1-569-907-11
1-774-701-11
PLUG, CONNECTOR (BUS CONTROL IN)
CONNECTOR, BOARD TO BOARD 30P
SOCKET, CONNECTOR 12P
PIN, CONNECTOR 16P
< JACK >
CNP801 1-764-270-21 JACK, STEREO MINIATURE (DIA.3.5)
(REMOTE IN)
< DIODE >
D701
D801
D802
D804
D805
8-719-991-33
8-719-083-66
8-719-069-56
8-719-058-24
8-719-083-66
DIODE
DIODE
DIODE
DIODE
DIODE
1SS133T-77
UDZS-TE-17-18B
UDZS-TE-17-6.2B
RB501V-40TE-17
UDZS-TE-17-18B
D806
D807
D808
D809
D810
8-719-083-66
8-719-991-33
8-719-988-61
8-719-988-61
8-719-988-61
DIODE
DIODE
DIODE
DIODE
DIODE
UDZS-TE-17-18B
1SS133T-77
1SS355TE-17
1SS355TE-17
1SS355TE-17
D811
D812
D813
D814
8-719-978-33
8-719-978-33
8-719-978-33
8-719-978-33
DIODE
DIODE
DIODE
DIODE
DTZ-TT11-6.8B
DTZ-TT11-6.8B
DTZ-TT11-6.8B
DTZ-TT11-6.8B
47
CDX-MP40
MAIN
Ref. No.
Part No.
Description
D815
D816
D817
D818
D819
8-719-978-33
8-719-978-33
8-719-978-33
8-719-988-61
8-719-988-61
DIODE
DIODE
DIODE
DIODE
DIODE
DTZ-TT11-6.8B
DTZ-TT11-6.8B
DTZ-TT11-6.8B
1SS355TE-17
1SS355TE-17
Remark
D901
D902
D903
D904
D905
8-719-200-82
8-719-200-82
8-719-200-82
8-719-200-82
8-719-200-82
DIODE
DIODE
DIODE
DIODE
DIODE
11ES2
11ES2
11ES2
11ES2
11ES2
D906
D907
D908
D909
D910
8-719-053-18
8-719-053-18
8-719-200-82
8-719-049-38
8-719-200-82
DIODE
DIODE
DIODE
DIODE
DIODE
1SR154-400TE-25
1SR154-400TE-25
11ES2
1N5404TU
11ES2
D911
D912
D915
D916
D917
8-719-200-82
8-719-978-33
8-719-200-82
8-719-069-55
8-719-929-15
DIODE
DIODE
DIODE
DIODE
DIODE
11ES2
DTZ-TT11-6.8B
11ES2
UDZS-TE-17-5.6B
HZS9.1N-B2
D918
D919
D920
D921
D923
8-719-988-61
8-719-109-89
8-719-988-61
8-719-988-61
8-719-200-82
DIODE
DIODE
DIODE
DIODE
DIODE
1SS355TE-17
RD5.6ES-B2
1SS355TE-17
1SS355TE-17
11ES2
D925
D926
D927
8-719-978-33 DIODE DTZ-TT11-6.8B
8-719-921-63 DIODE MTZJ-7.5B
8-719-069-55 DIODE UDZS-TE-17-5.6B
Ref. No.
JR806
JR807
JR904
JR906
Part No.
Description
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
Remark
0
0
0
0
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
5%
1/10W
< COIL >
L701
L702
L703
L704
L900
PJ401
1-414-235-22 INDUCTOR, FERRITE BEAD (AEP,UK)
1-469-144-21 FERRITE, EMI (SMD)
1-414-235-22 INDUCTOR, FERRITE BEAD
< IC >
6-703-304-01
8-759-827-14
6-703-809-01
8-759-679-05
6-802-685-01
IC
IC
IC
IC
IC
IC802
IC803
IC902
6-701-405-01 IC PST3443UL
8-759-096-16 IC MM1175XFF
6-703-986-01 IC NJU7222U33-TE1
BD3802F-FE2
TA8268AH
SAA6588T/V2-518 (AEP,UK)
TC7WH34FU(TE12R)
MN101C49KSJ
< JUMPER RESISTOR >
JR115
JR116
JR401
JR402
JR403
1-216-864-11
1-216-864-11
1-162-964-11
1-216-864-11
1-216-864-11
JR405
JR601
0
0
0.001uF
0
0
5%
5%
10%
5%
5%
1/10W
1/10W
50V
1/10W
1/10W
1-216-864-11 METAL CHIP
1-216-864-11 METAL CHIP
0
0
5%
5%
JR602
JR801
1-216-864-11 METAL CHIP
1-216-845-11 METAL CHIP
0
100K
5%
5%
JR803
1-216-864-11 METAL CHIP
0
5%
1/10W
1/10W
(AEP,UK)
1/10W
1/10W
(US,CND)
1/10W
JR805
1-216-864-11 METAL CHIP
0
5%
1/10W
48
METAL CHIP
METAL CHIP
CERAMIC CHIP
METAL CHIP
METAL CHIP
1-774-700-11 JACK, PIN 6P (BUS AUDIO IN,
AUDIO OUT REAR/FRONT)
1-793-598-11 JACK (ANTENNA)
< TRANSISTOR >
< FERRITE BEAD >
IC401
IC501
IC601
IC701
IC801
METAL CHIP
0
INDUCTOR
10uH
FERRITE, EMI (SMD)
INDUCTOR
10uH
COIL, CHOKE
250uH
< JACK >
PJ601
FB601
FB701
FB801
1-216-864-11
1-414-398-11
1-469-144-21
1-414-398-11
1-419-476-31
Q401
Q402
Q403
Q404
Q602
8-729-920-21
8-729-920-21
8-729-920-21
8-729-920-21
8-729-055-96
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTC314TK-T-146
DTC314TK-T-146
DTC314TK-T-146
DTC314TK-T-146
SRC1203SF (AEP,UK)
Q801
Q802
Q803
Q804
Q805
8-729-055-96
8-729-055-92
8-729-055-92
8-729-055-96
8-729-055-96
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
SRC1203SF
SRA2203SF
SRA2203SF
SRC1203SF
SRC1203SF
Q806
Q901
Q902
Q903
Q904
8-729-055-92
8-729-049-40
8-729-049-40
8-729-015-11
8-729-055-92
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
SRA2203SF
2SC5343SFG
2SC5343SFG
2SD1802FAST-TL
SRA2203SF
Q905
Q906
Q907
Q908
Q909
8-729-055-96
8-729-019-00
8-729-055-92
8-729-055-96
8-729-049-43
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
SRC1203SF
2SD2394-G
SRA2203SF
SRC1203SF
STB1132Y
Q910
Q911
Q912
Q913
Q914
8-729-055-96
8-729-049-40
8-729-019-00
8-729-055-92
8-729-055-96
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
SRC1203SF
2SC5343SFG
2SD2394-G
SRA2203SF
SRC1203SF
Q915
Q916
Q917
Q918
Q919
8-729-055-96
8-729-920-85
8-729-055-96
8-729-049-43
8-729-055-96
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
SRC1203SF
2SD1664-QR
SRC1203SF
STB1132Y
SRC1203SF
Q920
Q921
Q922
Q923
Q924
8-729-820-46
8-729-055-96
8-729-820-46
8-729-055-92
8-729-055-96
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SB1202FAS
SRC1203SF
2SB1202FAS
SRA2203SF
SRC1203SF
< RESISTOR >
R101
R102
R103
R104
1-216-833-11
1-216-809-11
1-216-809-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
100
100
10K
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
CDX-MP40
MAIN
Ref. No.
Part No.
Description
Part No.
Description
R111
R112
R201
R202
R203
1-218-882-11
1-216-833-11
1-216-833-11
1-216-833-11
1-216-825-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
30K
10K
10K
10K
2.2K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
Remark
Ref. No.
R821
R822
R823
R824
R825
1-216-809-11
1-216-809-11
1-216-833-11
1-216-833-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
10K
10K
1K
5%
5%
5%
5%
5%
Remark
1/10W
1/10W
1/10W
1/10W
1/10W
R204
R401
R402
R403
R404
1-216-825-11
1-247-807-31
1-247-807-31
1-247-807-31
1-247-807-31
METAL CHIP
CARBON
CARBON
CARBON
CARBON
2.2K
100
100
100
100
5%
5%
5%
5%
5%
1/10W
1/4W
1/4W
1/4W
1/4W
R826
R827
R828
R829
R830
1-216-864-11
1-216-845-11
1-247-807-31
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
CARBON
METAL CHIP
METAL CHIP
0
100K
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/4W
1/10W
1/10W
R405
R406
R407
R408
R409
1-247-807-31
1-216-841-11
1-216-809-11
1-216-841-11
1-216-809-11
CARBON
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
47K
100
47K
100
5%
5%
5%
5%
5%
1/4W
1/10W
1/10W
1/10W
1/10W
R831
R832
1-216-845-11 METAL CHIP
1-216-845-11 METAL CHIP
100K
100K
5%
5%
R833
R834
1-216-821-11 METAL CHIP
1-216-845-11 METAL CHIP
1K
100K
5%
5%
R410
R411
R412
R413
R414
1-216-841-11
1-247-807-31
1-216-841-11
1-216-821-11
1-216-833-11
METAL CHIP
CARBON
METAL CHIP
METAL CHIP
METAL CHIP
47K
100
47K
1K
10K
5%
5%
5%
5%
5%
1/10W
1/4W
1/10W
1/10W
1/10W
R835
1-216-845-11 METAL CHIP
100K
5%
1/10W
1/10W
(US,CND)
1/10W
1/10W
(AEP,UK)
1/10W
R415
R416
R417
R418
R419
1-216-821-11
1-216-833-11
1-216-841-11
1-216-825-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
10K
47K
2.2K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R836
R843
R866
R867
R868
1-216-864-11
1-216-845-11
1-216-845-11
1-216-845-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
100K
100K
100K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R420
R502
R505
R607
1-216-833-11
1-216-864-11
1-216-864-11
1-216-817-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
0
0
470
5%
5%
5%
5%
1-216-845-11
1-216-821-11
1-216-214-00
1-216-821-11
1-216-841-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
1K
4.7K
1K
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/8W
1/10W
1/10W
R608
1-216-797-11 METAL CHIP
10
5%
1/10W
1/10W
1/10W
1/10W
(AEP,UK)
1/10W
(AEP,UK)
R870
R901
R903
R904
R905
R906
R907
R908
R909
R910
1-216-833-11
1-216-833-11
1-216-841-11
1-216-841-11
1-216-829-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10K
47K
47K
4.7K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R609
1-216-827-11 METAL CHIP
3.3K
5%
R612
1-216-797-11 METAL CHIP
10
5%
R620
1-216-809-11 METAL CHIP
100
5%
R911
R913
R914
R915
R918
1-216-845-11
1-249-427-11
1-216-825-11
1-216-825-11
1-216-445-11
METAL CHIP
CARBON
METAL CHIP
METAL CHIP
METAL OXIDE
100K
6.8K
2.2K
2.2K
12
5%
5%
5%
5%
5%
1/10W
1/4W
1/10W
1/10W
2W
R702
R705
1-216-845-11 METAL CHIP
1-216-864-11 METAL CHIP
100K
0
5%
5%
1/10W
(AEP,UK)
1/10W
(AEP,UK)
1/10W
(AEP,UK)
1/10W
1/10W
R706
R707
R708
R801
R802
1-216-864-11
1-216-864-11
1-216-864-11
1-249-417-11
1-249-431-11
METAL CHIP
METAL CHIP
METAL CHIP
CARBON
CARBON
0
0
0
1K
15K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/4W
1/4W
R922
R923
R924
R925
R926
1-247-815-11
1-216-845-11
1-249-421-11
1-216-821-11
1-249-413-11
CARBON
METAL CHIP
CARBON
METAL CHIP
CARBON
220
100K
2.2K
1K
470
5%
5%
5%
5%
5%
1/4W
1/10W
1/4W
1/10W
1/4W
R804
R805
R806
R807
R811
1-247-807-31
1-216-809-11
1-469-144-21
1-469-144-21
1-216-845-11
CARBON
100
METAL CHIP
100
FERRITE, EMI (SMD)
FERRITE, EMI (SMD)
METAL CHIP
100K
5%
5%
1/4W
1/10W
R927
R930
R931
R932
R934
1-249-417-11
1-216-845-11
1-249-421-11
1-216-805-11
1-216-845-11
CARBON
METAL CHIP
CARBON
METAL CHIP
METAL CHIP
1K
100K
2.2K
47
100K
5%
5%
5%
5%
5%
1/4W
1/10W
1/4W
1/10W
1/10W
R935
1-249-421-11 CARBON
2.2K
5%
1/4W
5%
1/10W
R812
R813
R814
R815
R816
1-216-841-11
1-216-821-11
1-216-821-11
1-216-821-11
1-216-813-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
1K
1K
1K
220
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R817
R818
R819
R820
1-216-809-11
1-216-809-11
1-216-837-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
22K
100
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
< SWITCH >
S801
S802
1-762-638-21 SWITCH, TACTILE (RESET)
1-786-458-11 SWITCH, PUSH (1 KEY) (NOSE DET)
49
CDX-MP40
MAIN
Ref. No.
RELAY
Part No.
SERVO
Description
Remark
< THERMISTOR (POSITIVE) >
TH900
TH901
1-801-792-21 THERMISTOR, POSITIVE
1-810-940-11 THERMISTOR, POSITIVE
Ref. No.
Part No.
Description
C13
C14
C15
C16
C17
1-162-916-11
1-125-837-11
1-162-970-11
1-162-970-11
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
12PF
1uF
0.01uF
0.01uF
0.01uF
5%
10%
10%
10%
10%
50V
6.3V
25V
25V
25V
Remark
C18
C19
C20
C21
C22
1-162-966-11
1-107-826-11
1-107-826-11
1-162-970-11
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.0022uF
0.1uF
0.1uF
0.01uF
0.01uF
10%
10%
10%
10%
10%
50V
16V
16V
25V
25V
C23
C24
C25
C27
C29
1-162-970-11
1-162-970-11
1-162-970-11
1-125-837-11
1-162-964-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.01uF
0.01uF
1uF
0.001uF
10%
10%
10%
10%
10%
25V
25V
25V
6.3V
50V
C30
C34
C35
C36
C38
1-162-970-11
1-125-837-11
1-162-970-11
1-162-970-11
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
1uF
0.01uF
0.01uF
0.01uF
10%
10%
10%
10%
10%
25V
6.3V
25V
25V
25V
C39
C40
C41
C43
C44
1-126-391-11
1-107-826-11
1-162-970-11
1-162-967-11
1-162-964-11
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
47uF
0.1uF
0.01uF
0.0033uF
0.001uF
20%
10%
10%
10%
10%
6.3V
16V
25V
50V
50V
C45
C51
C53
C54
C55
1-162-970-11
1-107-826-11
1-107-826-11
1-107-826-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.1uF
0.1uF
0.1uF
0.1uF
10%
10%
10%
10%
10%
25V
16V
16V
16V
16V
C56
C57
C58
C59
C60
1-128-934-11
1-107-826-11
1-162-966-11
1-104-609-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
0.33uF
0.1uF
0.0022uF
100uF
0.1uF
20%
10%
10%
20%
10%
10V
16V
50V
4V
16V
C61
C62
C63
C65
C67
1-126-391-11
1-107-826-11
1-107-826-11
1-107-826-11
1-104-851-11
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
TANTAL. CHIP
47uF
0.1uF
0.1uF
0.1uF
10uF
20%
10%
10%
10%
20%
6.3V
16V
16V
16V
10V
C68
C69
C70
C75
C77
1-107-826-11
1-107-826-11
1-107-826-11
1-107-826-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
10%
10%
10%
10%
10%
16V
16V
16V
16V
16V
C78
C79
C81
C102
C111
1-162-964-11
1-125-837-11
1-107-826-11
1-162-927-11
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.001uF
1uF
0.1uF
100PF
0.01uF
10%
10%
10%
5%
10%
50V
6.3V
16V
50V
25V
C112
C113
C114
1-107-826-11 CERAMIC CHIP
1-162-970-11 CERAMIC CHIP
1-107-826-11 CERAMIC CHIP
0.1uF
0.01uF
0.1uF
10%
10%
10%
16V
25V
16V
< TUNER >
TUX501 A-3220-887-A TUNER UNIT (TUX-030)
< VIBRATOR >
X601
1-760-556-31 VIBRATOR, CRYSTAL (4.332MHz) (AEP,UK)
X801
1-795-165-11 VIBRATOR, CERAMIC (18.43MHz)
X802
1-567-098-41 VIBRATOR, CRYSTAL (32.768kHz)
*************************************************************
RELAY BOARD
************
1-792-173-11 CABLE, FLAT (FFC) 12P (CNP903)
< CAPACITOR >
C973
C974
1-107-826-11 CERAMIC CHIP
1-107-826-11 CERAMIC CHIP
0.1uF
0.1uF
10%
10%
16V
16V
< CONNECTOR >
CNP902 1-817-159-11 SOCKET, CONNECTOR 14P
< DIODE >
D901
D902
D903
D904
D905
8-719-978-33
8-719-978-33
8-719-978-33
8-719-978-33
8-719-978-33
DIODE
DIODE
DIODE
DIODE
DIODE
DTZ-TT11-6.8B
DTZ-TT11-6.8B
DTZ-TT11-6.8B
DTZ-TT11-6.8B
DTZ-TT11-6.8B
D906
D907
LED930
LED931
8-719-978-33
8-719-978-33
8-719-082-38
8-719-053-09
DIODE DTZ-TT11-6.8B
DIODE DTZ-TT11-6.8B
LED CL-270SR-C-TS (CD WINDOW)
LED SML-310VT-T86 (Z)
< RESISTOR >
R930
R931
R932
1-216-823-11 METAL CHIP
1-216-823-11 METAL CHIP
1-216-823-11 METAL CHIP
1.5K
1.5K
1.5K
5%
5%
5%
1/10W
1/10W
1/10W
< SWITCH >
S931
1-771-884-31 SWITCH, TACTILE (WITH LED) (Z)
*************************************************************
A-3274-698-A SERVO BOARD, COMPLETE
**********************
< CAPACITOR >
C1
C3
C4
C5
C6
1-162-970-11
1-162-970-11
1-104-609-11
1-162-970-11
1-125-837-11
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.01uF
100uF
0.01uF
1uF
10%
10%
20%
10%
10%
25V
25V
4V
25V
6.3V
C8
C9
C10
C11
1-107-826-11
1-162-924-11
1-162-924-11
1-162-909-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
56PF
56PF
4PF
10%
5%
5%
0.25PF
16V
50V
50V
50V
< CONNECTOR >
50
CN1
CN2
CN3
1-815-352-11 CONNECTOR, BOARD TO BOARD 30P
1-794-153-21 CONNECTOR, FPC (ZIF) 16P
1-816-275-21 CONNECTOR, FFC/FPC 6P
CDX-MP40
SERVO
Ref. No.
Part No.
Description
Remark
< FERRITE BEAD >
FB2
FB3
FB6
1-216-864-11 METAL CHIP
0
1-216-864-11 METAL CHIP
0
1-469-144-21 FERRITE, EMI (SMD)
5%
5%
1/10W
1/10W
< IC >
IC1
IC2
IC3
IC4
IC5
8-759-699-98
8-759-658-87
6-703-905-01
6-702-661-01
6-702-153-01
IC
IC
IC
IC
IC
uPD63711GC-8EU
BA5810FP-E2
HD6432238RWN35TEI
UT62L1024LC-55LLI
CXD9684R-005
IC6
IC7
IC12
8-759-645-31 IC RN5RZ25BA-TL-FA
8-759-491-50 IC TC74VHCT244AFT(EL)
8-759-196-96 IC TC7SH08FU-TE85R
< JUMPER RESISTOR >
JR1
JR3
JR5
JR6
JR12
1-216-821-11
1-216-864-11
1-216-821-11
1-216-864-11
1-216-864-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
0
1K
0
0
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
JR13
JR14
JR15
JR17
JR21
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
0
0
0
0
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
5%
1/10W
< COIL >
L4
L6
L8
1-216-001-00 METAL CHIP
10
1-469-144-21 FERRITE, EMI (SMD)
1-414-398-11 INDUCTOR
10uH
< TRANSISTOR >
Q1
8-729-904-87 TRANSISTOR 2SB1197K-R
< RESISTOR >
R3
R5
R7
R8
R9
1-216-806-11
1-218-344-11
1-216-839-11
1-216-833-11
1-216-840-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
56
7.5K
33K
10K
39K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R10
R12
R13
R14
R15
1-216-835-11
1-216-837-11
1-216-807-11
1-216-841-11
1-216-841-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
15K
22K
68
47K
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R26
R29
R30
R45
R46
1-216-806-11
1-216-833-11
1-216-833-11
1-216-845-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
56
10K
10K
100K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R47
R48
R49
R50
R51
1-216-845-11
1-216-845-11
1-216-845-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
100K
100K
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R52
1-216-809-11 METAL CHIP
100
5%
1/10W
Ref. No.
Part No.
Description
R53
R54
R55
R64
R65
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-819-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
100
680
5%
5%
5%
5%
5%
Remark
1/10W
1/10W
1/10W
1/10W
1/10W
R67
R68
R69
R70
R71
1-216-845-11
1-216-857-11
1-216-813-11
1-216-813-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
1M
220
220
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R72
R73
R74
R75
R76
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R77
R78
R81
R82
R83
1-216-809-11
1-216-809-11
1-216-845-11
1-216-845-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100K
100K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R84
R85
R86
R87
R88
1-216-845-11
1-216-845-11
1-216-845-11
1-216-845-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
100K
100K
100K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R89
R90
R91
R92
R93
1-216-845-11
1-216-845-11
1-216-845-11
1-216-845-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
100K
100K
100K
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R94
R95
R96
R97
R98
1-216-809-11
1-216-809-11
1-216-809-11
1-216-837-11
1-216-834-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
22K
12K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R100
R102
R103
R104
R105
1-216-845-11
1-216-845-11
1-216-845-11
1-216-845-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
100K
100K
100K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R106
R107
R109
R111
R113
1-216-821-11
1-216-821-11
1-216-845-11
1-216-845-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
100K
100K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R114
R115
R116
R117
R118
1-216-845-11
1-216-837-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
22K
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R119
R121
R124
R126
R127
1-216-821-11
1-216-845-11
1-216-837-11
1-216-845-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
100K
22K
100K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R128
R129
R130
1-216-845-11 METAL CHIP
1-216-845-11 METAL CHIP
1-216-809-11 METAL CHIP
100K
100K
100
5%
5%
5%
1/10W
1/10W
1/10W
51
CDX-MP40
SERVO
Ref. No.
Part No.
Description
R131
R132
R133
R134
R135
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
100
100
5%
5%
5%
5%
5%
Remark
1/10W
1/10W
1/10W
1/10W
1/10W
R136
R142
R143
R144
R145
1-216-809-11
1-216-815-11
1-218-484-11
1-216-812-11
1-216-817-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
330
750
180
470
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R146
R147
R148
R149
R150
1-216-815-11
1-218-484-11
1-216-809-11
1-216-814-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
330
750
100
270
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R151
R152
R153
R154
1-216-825-11
1-216-813-11
1-216-818-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
220
560
100
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
Ref. No.
Part No.
Description
Remark
PARTS FOR INSTALLATION AND CONNECTIONS
***************************************
251
252
253
254
255
X-3382-647-1
X-3366-405-1
3-246-035-01
3-934-325-01
1-465-459-21
256
257
1-776-207-82 CORD (WITH CONNECTOR) (POWER) (US,CND)
1-776-527-61 CORD (WITH CONNECTOR) (ISO) (POWER)
(AEP,UK)
3-246-471-01 KEY (FRAME)
258
FRAME ASSY, FITTING
SCREW ASSY (EXP), FITTING (AEP,UK)
COLLAR
SCREW (+K 5X8 TP) (US,CND)
ADAPTOR, ANTENNA (AEP,UK)
251
252
253
254
255
256
257
258
< NETWORK RESISTOR >
RB1
RB2
1-233-576-11 RES, CHIP NETWORK 100X4
1-233-576-11 RES, CHIP NETWORK 100X4
< VIBRATOR >
X1
1-795-520-11 VIBRATOR, CERAMIC (16.9344MHz)
X2
1-795-127-21 VIBRATOR, CERAMIC (12.288MHz)
*************************************************************
MISCELLANEOUS
***************
9
9
207
0 210
211
1-776-207-82 CORD (WITH CONNECTOR) (POWER) (US,CND)
1-776-527-61 CORD (WITH CONNECTOR) (ISO) (POWER)
(AEP,UK)
1-823-951-11 CABLE, FLEXIBLE FLAT (16 CORE)
8-820-165-06 OPTICAL PICK-UP KSS-721A/C-RP
1-676-707-11 PICK-UP FLEXIBLE BOARD
F901
1-532-877-11 FUSE (BLADE TYPE) (AUTO FUSE) 10A
M902
A-3301-985-A MOTOR ASSY, SLED (SLED)
M903
A-3315-039-A MOTOR SUB ASSY, LO (LOADING)
*************************************************************
ACCESSORIES
************
1-476-526-34 REMOTE COMMANDER (RM-X115)
3-230-047-01 LID, BATTERY CASE (for RM-X115)
3-251-806-11 MANUAL, INSTRUCTION (ENGLISH,FRENCH)
(US,CND)
3-251-806-31 MANUAL, INSTRUCTION (ENGLISH,GERMAN,
FRENCH,ITALIAN,DUTCH) (AEP,UK)
3-251-853-11 MANUAL, INSTRUCTION, INSTALL (ENGLISH,
FRENCH) (US,CND)
3-251-853-31 MANUAL, INSTRUCTION, INSTALL (ENGLISH,
GERMAN,FRENCH,ITALIAN,DUTCH) (AEP,UK)
X-3378-390-3 CASE ASSY (for FRONT PANEL) (US,CND)
X-3378-490-2 CASE (PANEL) ASSY (for FRONT PANEL)
(AEP,UK)
*************************************************************
52
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
Les composants identifiés par une
marque 0 sont critiques pour
la sécurité.
Ne les remplacer que par une piéce
portant le numéro spécifié.
CDX-MP40
MEMO
53
CDX-MP40
REVISION HISTORY
Clicking the version allows you to jump to the revised page.
Also, clicking the version at the upper right on the revised page allows you to jump to the next revised
page.
Ver.
1.0
54
Date
2003. 01
Description of Revision
New