Download Sony CDX-L410X CD Player

CDX-L410X
SERVICE MANUAL
US Model
Canadian Model
Ver 1.1 2003. 06
• The tuner and CD sections have no adjustments.
AUDIO POWER SPECIFICATIONS (US Model)
POWER OUTPUT AND TOTAL HARMONIC DISTORTION
22 watts per channel minimum continuous average power into
4 ohms, 4 channels driven from 20 Hz to 20 kHz with no more
than 5% total harmonic distortion.
Model Name Using Similar Mechanism
CDX-L280
CD Drive Mechanism Type
MG-393XC-121//K
Optical Pick-up Name
KSS-721A
SPECIFICATIONS
CD player section
Signal-to-noise ratio
Frequency response
Wow and flutter
General
90 dB
10 – 20,000 Hz
Below measurable limit
Inputs
Tone controls
Tuner section
FM
Tuning range
Antenna terminal
Intermediate frequency
Usable sensitivity
Selectivity
Signal-to-noise ratio
87.5 – 107.9 MHz
External antenna connector
10.7 MHz
11 dBf
75 dB at 400 kHz
65 dB (stereo),
68 dB (mono)
Harmonic distortion at 1 kHz
0.7% (stereo),
0.5% (mono)
Separation
33 dB at 1 kHz
Frequency response
30 – 15,000 Hz
AM
Tuning range
Antenna terminal
Intermediate frequency
Sensitivity
Outputs
Power requirements
Dimensions
Mounting dimensions
Mass
Supplied accessories
Audio outputs (rear)
Power antenna relay control terminal
Power amplifier control terminal
Antenna input terminal
Low: ±10 dB at 60 Hz (XPLOD)
Mid: ±10 dB at 1 kHz (XPLOD)
High: ±10 dB at 10 kHz (XPLOD)
12 V DC car battery
(negative ground)
Approx. 178 × 50 × 176 mm
(7 1/8 × 2 × 7 in.) (w/h/d)
Approx. 182 × 53 × 161 mm
(7 1/4 × 2 1/8 × 6 3/8 in.) (w/h/d)
Approx. 1.2 kg
(2 lb. 10 oz.)
Parts for installation and connections
Front panel case (1)
Note
This unit cannot be connected to a digital preamplifier or an equalizer.
530 – 1,710 kHz
External antenna connector
10.7 MHz/450 kHz
AM: 30 µV
Design and specifications are subject to change without
notice.
Power amplifier section
Outputs
Speaker outputs
(sure seal connectors)
Speaker impedance
4 – 8 ohms
Maximum power output 45 W × 4 (at 4 ohms)
FM/AM COMPACT DISC PLAYER
9-874-230-02
Sony Corporation
2003F04-1
© 2003. 06
e Vehicle Company
Published by Sony Engineering Corporation
1
CDX-L410X
SERVICE NOTES
NOTES ON HANDLING THE OPTICAL PICK-UP BLOCK
OR BASE UNIT
The laser diode in the optical pick-up block may suffer electrostatic
breakdown because of the potential difference generated by the
charged electrostatic load, etc. on clothing and the human body.
During repair, pay attention to electrostatic breakdown and also use
the procedure in the printed matter which is included in the repair
parts.
The flexible board is easily damaged and should be handled with
care.
NOTES ON LASER DIODE EMISSION CHECK
The laser beam on this model is concentrated so as to be focused on
the disc reflective surface by the objective lens in the optical pickup block. Therefore, when checking the laser diode emission, observe from more than 30 cm away from the objective lens.
CAUTION
Use of controls or adjustments or performance of procedures
other than those specified herein may result in hazardous
radiation exposure.
If the optical pick-up block is defective, please replace the whole
optical pick-up block.
Never turn the semi-fixed resistor located at the side of optical
pick-up block.
optical pick-up block
Notes on Chip Component Replacement
• Never reuse a disconnected chip component.
• Notice that the minus side of a tantalum capacitor may be damaged by heat.
semi-fixed resistor
TEST DISCS
This set can playback CD-R and CD-ROM discs. The following
test discs should be used to check the capability:
CD-R test disc TCD-R082LMT (Part No. J-2502-063-1)
CD-RW test disc TCD-W082L (Part No. J-2502-063-2)
Notes on CD-R/CD-RW discs
• You can play CD-Rs (recordable CDs)/CD-RWs (rewritable CDs)
designed for audio use on this unit.
Look for these marks to distinguish CD-Rs/CD-RWs for audio
use.
These marks denote that a disc is not for audio use.
• Some CD-Rs/CD-RWs (depending on the equipment used for
its recording or the condition of the disc) may not play on this
unit.
• You cannot play a CD-R/CD-RW that is not finalized∗.
∗ A process necessary for a recorded CD-R/CD-RW disc to be
played on the audio CD player.
SAFETY-RELATED COMPONENT WARNING!!
ATTENTION AU COMPOSANT AYANT RAPPORT
À LA SÉCURITÉ!!
COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE
WITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN
THE PARTS LIST ARE CRITICAL TO SAFE OPERATION.
REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE
PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR
IN SUPPLEMENTS PUBLISHED BY SONY.
LES COMPOSANTS IDENTIFIÉS PAR UNE MARQUE 0 SUR LES
DIAGRAMMES SCHÉMATIQUES ET LA LISTE DES PIÈCES
SONT CRITIQUES POUR LA SÉCURITÉ DE FONCTIONNEMENT.
NE REMPLACER CES COMPOSANTS QUE PAR DES PIÈCES
SONY DONT LES NUMÉROS SONT DONNÉS DANS CE MANUEL
OU DANS LES SUPPLÉMENTS PUBLIÉS PAR SONY.
2
CDX-L410X
TABLE OF CONTENTS
3. DIAGRAMS
1. GENERAL
Location of controls ................................................................. 4
Connections ............................................................................. 4
2. DISASSEMBLY
2-1. Sub Panel (1) Assy .............................................................. 6
2-2. CD Mechanism Block ......................................................... 7
2-3. Main Board ......................................................................... 7
2-4. Heat Sink ............................................................................. 8
2-5. Chassis (T) Sub Assy .......................................................... 8
2-6. Lever Section, In Self Sw Board ......................................... 9
2-7. Servo Board ......................................................................... 9
2-8. Shaft Roller Assy, Load Sw Board .................................... 10
2-9. Floating Block Assy .......................................................... 10
2-10. Optical Pick-up Block ....................................................... 11
3-1. IC Pin Description ............................................................. 12
3-2. Circuit Boards Location .................................................... 14
3-3. Block Diagram –CD Section– ........................................... 15
3-4. Block Diagram –Tuner Section– ....................................... 16
3-5. Block Diagram –Display Section– .................................... 17
3-6. Printed Wiring Boards –CD Mechanism Section– ............ 18
3-7. Schematic Diagram –CD Mechanism Section– ................ 20
3-8. Printed Wiring Boards –Main Section– ............................ 21
3-9. Schematic Diagram –Main Section (1/2)– ........................ 22
3-10. Schematic Diagram –Main Section (2/2)– ........................ 23
3-11. Printed Wiring Board –Display Section– .......................... 24
3-12. Schematic Diagram –Display Section– ............................. 25
3-13. IC Block Diagrams ............................................................ 26
4. EXPLODED VIEWS
4-1.
4-2.
4-3.
4-4.
4-5.
Chassis Section ................................................................. 28
Front panel Section ........................................................... 29
CD Mechanism Section (1) ............................................... 30
CD Mechanism Section (2) ............................................... 31
CD Mechanism Section (3) ............................................... 32
5. ELECTRICAL PARTS LIST ........................................ 33
EXTENSION CABLE AND SERVICE POSITION
When repairing or servicing this set, connect the jig (extension cable)
as shown below.
• Connect the MAIN board (CNP701) and the SERVO board (CN1)
with the extension cable (Part No. J-2502-062-1).
MAIN BOARD CNP701
SERVO BOARD CN1
3
CDX-L410X
SECTION 1
GENERAL
Connections
4
This section is extracted
from instruction manual.
CDX-L410X
5
CDX-L410X
SECTION 2
DISASSEMBLY
Note : This set can be disassemble according to the following sequence.
SET
2-1.
SUB PANEL (1) ASSY
(Page 6)
2-2.
CD MECHANISM BLOCK
(Page 7)
2-3.
MAIN BOARD
(Page 7)
2-4.
2-5.
CHASSIS (T) SUB ASSY
(Page 8)
2-6.
LEVER SECTION
IN SELF SW BOARD
(Page 9)
2-7.
2-8.
SHAFT ROLLER ASSY
LOAD SW BOARD
(Page 10)
2-9.
FLOATING BLOCK ASSY
(Page 10)
2-10.
OPTICAL PICK-UP BLOCK
(Page 11)
HEAT SINK
(Page 8)
SERVO BOARD
(Page 9)
Note : Follow the disassembly procedure in the numerical order given.
2-1. SUB PANEL (1) ASSY
3 claws
2 claws
1 PTT 2.6x6
4 sub panel (1) assy
6
CDX-L410X
2-2. CD MECHANISM BLOCK
7 bracket (CD)
5 CD mechanism block
6 PTT 2.6x6
2 PTT 2.6x6
3
1 PTT 2.6x6
4 CNP701
2-3. MAIN BOARD
5 MAIN board
3 screw (+BTT)
4 screws (+BTT)
2 PTT 2.6x8
1 PTT 2.6x8
7
CDX-L410X
2-4. HEAT SINK
6 heat sink
5 PTT 2.6x8
4 PTT 2.6x8
3 PTT 2.6x12
2 PTT 2.6x8
1 PTT 2.6x8
2-5. CHASSIS (T) SUB ASSY
2 P 2x3
3 P 2x3
1 Unsolder the
lead wires.
black
red
white
8
4 chassis (T) sub assy
CDX-L410X
2-6. LEVER SECTION, IN SELF SW BOARD
5 guide (disc)
6 lever (R)
3 tension spring (LR)
7 lever (L)
1 special screw
2 IN SELF SW board
4 claws
2-7. SERVO BOARD
8 SERVO board
7 special screw
6 special screws
2 Removal the solders.
9 connector
1 CN3
4 P 2x3
3 Unsolder the
lead wires.
black
5 loading motor assy
yellow
optical pick-up block
9
CDX-L410X
2-8. SHAFT ROLLER ASSY, LOAD SW BOARD
• When installing, take note of the positions
arm (roller) and washers. (Fig. 1)
3 retaing ring (RA)
shaft retainer (roller)
washer
4 shaft retainer (roller) retaing ring
arm
(RA)
arm
washer
shaft retainer
(roller)
Fig. 1
6 special screw
5 shaft roller assy
2 arm (roller)
7 LOAD SW board
1 tension spring (RA)
2-9. FLOATING BLOCK ASSY
6 floating block assy
7 compression spring (FL)
1 tension spring (KF1)
8 compression spring (FL)
4 Fit lever (D) in the
direction of the arrow.
5 Turn loading ring in the
direction of the arrow.
2 damper (T)
3 damper (T)
10
CDX-L410X
2-10. OPTICAL PICK-UP BLOCK
1 P 2x3
4 screw
5 plate spring (feed)
2 sled motor assy
6 shaft (feed) assy
3 optical pick-up block
11
CDX-L410X
SECTION 3
DIAGRAMS
3-1. IC PIN DESCRIPTION
• IC801 µPD780076YGK-R24 (SYSTEM CONTROL) (MAIN Board)
Pin No.
Pin Name
I/O
Pin Description
1
D SW
I
Down switch detection signal input “L”: Down switch on
2
3
LM LD
LM EJ
O
O
Loading motor drive control signal output (Loading direction)
Loading motor drive control signal output (Eject direction)
4
5
ATT
A ATT
O
O
Mute control signal output of audio signal line “H”: mute on
Mute control signal output to power amp IC (IC101) “L”: amp mute on
6
7
PLL DI
VOL ATT
I
O
Serial data signal input to PLL IC (IC601)
Mute control signal output to Electric volume IC (IC401)
8
9
DOOR SW/IND
VSS0
I
—
Door switch signal input Case of flipdown, sense to open condition of door “H”: open
Ground pin
10
11
VDD0
PLL CE
—
O
Power supply pin
Chip enable signal output to PLL IC (IC601)
12
13
BEEP
SDAO
O
O
Beep signal output of key beep, caution alarm to power amp IC (IC101)
IIC data line signal output (control to electric volume IC (IC401))
14
15
SCLO
LCD CE
O
O
IIC clock line signal output (control to electric volume IC (IC401))
Chip enable control signal output to LCD driver IC (IC901)
16
17
LCD DO
LCD CLK
O
O
Serial data signal output to LCD driver IC (IC901)
Serial clock signal output to LCD driver IC (IC901)
18
19
BUS SI
BUS SO
I
O
SONY bus data signal input
SONY bus data signal output
20
21
BUS CLK
BUS CLK GEN
I
O
SONY bus clock signal input
SONY bus clock signal output
22
AM ON
O
23
FM ON
O
24
VDD1
—
25
AVSS
—
Ground pin
Stereo signal input/monaural control signal output
26
ST IND
I/O
At forced monaural on: “L” output
At forced monaural off: input mode, stereo on for “L” input
27
28
SHIFT/PH1
S METER
I
I
Rotary commander shift key signal input Not used in this set.
S meter signal input from tuner unit (TU601)
29, 30
KEY0, KEY1
I
31
R COM
I
A/D key signal input Input of A/D key matrix and front panel attachment decision.
Rotary commander AD level signal input
32
DST SEL
I
Sense to key voltage level of rotary commander
Destination select input
33
34
TEST
AVREF
I
—
Test mode select signal input “L”: test mode
Analog reference voltage pin
35
36
AD ON
RESET
O
I
LCD INHIBIT signal output Not used in this set.
Reset signal input from reset IC (IC902) “H”: reset
37
38
XT2
XT1
—
—
Connect to sub clock (32.768 kHz)
Connect to sub clock (32.768 kHz)
39
40
IC
X2
—
—
At on board writer: 12 V power supply pin (usually ground pin)
Connect to crystal oscillator (8.38 MHz)
41
42
X1
VSS1
—
—
Connect to crystal oscillator (8.38 MHz)
Ground pin
43
44
KEY ACK
SIRCS
I
I
Key acknowledge signal input
Wireless remote control signal input from remote control receiver IC (IC951)
45
46
SELF SW
BU IN
I
I
SELF switch detection signal input “L”: SELF switch on
Backup power supply detection signal input
47
NOSE
I
Front panel attachment detection signal input from SW801 “L”: panel on
12
AM select signal output
FM circuit power supply control output of tuner unit (TU601)
FM select signal output
FM circuit power supply control output of tuner unit (TU601)
Power supply pin
“H”: FM on
“H”: FM on
CDX-L410X
Pin No.
48
Pin Name
ILL ON
I/O
O
Pin Description
Front panel illumination power supply control signal output
49
50
A REMO
CDM ON
O
O
External amplifier remote control signal output
CD mechanism deck power supply control signal output “H”: CD power on
51
52
XCD ON
ACC IN
O
I
CD DSP power supply control signal output “H”: CD power on
Accessory power supply detection signal input “L”: accessory on
53
54
BUS ON
BUS RST
O
O
SONY bus on signal output Not used in this set. (open)
SONY bus reset signal output Not used in this set. (open)
55
56
PW ON
X SO PLL SO
O
O
System power supply control signal output
CD and PLL serial data signal output
57
58
X SI
X SCK PLL SCK
I
O
CD serial data signal input
CD and PLL serial data signal output
59
60
RF OK
CD RST
I
O
CD RF OK signal input
CD reset control signal output
61
62
IN SW/PH2
X AO
I
O
DISC IN switch detection signal input “L”: DISC IN switch on
Parameter/command select signal output
63
64
STB
L SW
O
I
CD strobe signal output
LIMIT switch detection signal input “L”: LIMIT switch on
“H”: illumination on
13
CDX-L410X
3-2. CIRCUIT BOARDS LOCATION
SERVO board
IN SELF SW board
SPEAKER board
LOAD SW board
tuner unit
(TU601)
DISPLAY board
MAIN board
SL SW board
14
CDX-L410X
3-3. BLOCK DIAGRAM — CD SECTION —
RF AMP,DIGITAL SERVO
DIGITAL SIGNAL PROCESSOR
IC1
OPTICAL PICK-UP
KSS-721A
A
84
C
85
B
TUNER
SECTION
D
RF
EQ
A
B
82
DSUB CODE
PROCESS
C
I-V
CONV.
D
LOUT
16
ROUT
12
D/A
CONV
EFM
DEMOD
83
FORCUS
ERROR
I/F
E
E
87
F
86
PD
97
PD
SERVO
CTL
A+5V
XTALEN
62 63 64 65
FOCUS/TRACKING COIL DRIVE,
SLED/SPINDLE/LOADING MOTOR DRIVE
IC2
FCSFOCUS
COIL
FCS+
TRK+
TRACKING
COIL
TRK-
15
16
17
18
FOCUS
COIL
DRIVE
TRACKING
COIL
DRIVE
26
23
23
M
SLSL+
M901
(SPINDLE)
M
M903
(LOADING)
M
SP+
SP-
LD-
13
14
11
12
9
LD+ 10
SLED
MOTOR
DRIVE
5
SPINDLE
MOTOR
DRIVE
6
LOADING
MOTOR
DRIVE
SYSTEM CONTROL
IC801(1/3)
D+5V
56 X_SO/PLL_SO
57 X_SI
58 X_SCK/PLL_SCK
63 STB
62 X A0
60 CD_RST
2
59 RFOK
PLL DO
PLL CLK
9
X EN
B
TUNER
SECTION
(Page 16)
24
X1
16.9344MHz
FD
1 D_SW
SW1
(DOWN)
45 SELF_SW
SW2
(SELF)
TD
61 IN_SW
SW3
(DISC IN)
M902
(SLED)
A
(Page 16)
MD
SD
LD
TD
OSC
98
PACK
52
TSTB
56
TSCK
55
TSI
54
SI
8
SO
7
SCK
6
STB
5
AO
4
RST
3
RFOK
APC
FD
LD
DRIVE
Q1
LD
F
TRACKING
ERROR
CDL
R-CH
64 L_SW
SW4
(LIMIT)
SD
IC902
RESET 36
1
1
RESET
2
U_COM+5V
MD
SW802
(RESET)
LOAD
2 LM _LD
EJECT
2
3 LM_ EJ
A+5V
AU+5V
CD MECHANISM
ON SWITCH
Q905,906
CD+5V
REG
Q910,D911
D909
CD ON
SWITCH
Q921
D+5V
CD DRIVE
+6V REG
Q907,D908
DR+6V
15
50 CDM ON
BATT
15
51 XCD_ON
• Signal path
:CD
• R-ch is omitted due to
same as L-ch.
CDX-L410X
3-4. BLOCK DIAGRAM — TUNER SECTION —
PJ401
-1
L
REAR AUDIO OUT
-2
R
R-CH
A
TUNER UNIT
TU601
CNJ601
(ANTENNA)
CDR
CD
SECTION
L-CH 16
R-CH 17
1 AM_ANT DET_OUT 24
CDL
R-CH
R-CH
C
OUTF1 15
12
OUTR1 14
11
9
7
9 C2
6
7
10
11
B1
B2
D1
D2
OUTF2 13
OUTR2 12
LINE MUTE
Q102
SDA 21
SCL 20
MUTE 19
LCD CLK
LCD DO
LCD CE
AM_DX/LCL 3
FM_DX/LCL 4
8 LCL
FM/AM_OSC 11
15 FM_VCO
16 AM_VCO
18 FM_CP
19 VT
20 AM_CP
2
10
13
11
13
• FM/AM_VCC
25
TU+8V
FM POWER
CONTROL
Q605,606
AM POWER
CONTROL
Q603,604
OSC
SEEK
IFC
MONO
17 LCD CLK
16 LCD DO
15 LCDCE
6
4
5
3
LINE MUTE
CONTROL
Q401,402
PLL CLK
X EN
TU+8V
TUNER +8V
REG
Q913,D913
B
ATT
BEEP
PW ON
A_ATT
4
12
55
5
ACC
CHECK
Q902
7 ACC
15 TEST
BATT
SCLO 14
SDAO 13
AMP REMOTE
CONTROL
Q911,917
5 AMP REM
ANT REMOTE
CONTROL
Q903,916
A REMO 49
XO 1
XI 24
32 DST SEL
47 NOSE
PLL DO
VOL_ATT 7
11 PLL_CE
U COM+5V
TUNER ON
CONTROL
Q909,912
R-CH
TEST 33
28 S_METER
26 ST_IND
9 AM_VCC
D933
4 FR+
12 FR–
4 STBY
22 MUTE
3 RR+
11 RR–
6 PLL_DI
S_METER 21
SD/ST_IND 22
D932
LINE MUTE
Q101
ACC IN 52
D_OUT
D_IN
CK
CE
X601
10.25MHz
12 FM_VCC
2 RL+
10 RL–
R-CH
PLL
IC601
OSC-IN 19
IF_COUNT 20
1 FL+
9 FL–
16 AUX-IN
R-CH
SYSTEM CONTROL
IC801 (2/3)
FM_VT 6
AM_VT 14
CNP901
5
3
8 C1
2 FM_ANT
DISPLAY
SECTION
(Page 17)
POWER AMP
IC101
ELECTRONIC VOLUME
IC401
(Page 15)
BUS SI
BUS SO
BUS CLK
BUS CK GEN
18
19
20
21
COM+8V
6 ANT REM
8
COM+8V REG
Q918,919,929,D923
GND
17
19
BU IN 46
FM_ON 23
U_COM+5V
U_COM+5 V REG
Q920,D930,D999
BATT
F901
10A
18
AM_ON 22
16 +B (BATT)
BATT
CHECK
Q904,D907
CD
SECTION
(Page 15)
UCOM+5V
BATT
DETECT
Q833,834,D809
• Signal path
:FM
:AM
:CD
• R-ch is omitted due to
BATT
same as L-ch.
16
16
CDX-L410X
• Waveforms
— Servo Board —
3-5. BLOCK DIAGRAM — DISPLAY SECTION —
— Main Board —
(MODE: CD PLAY)
TUNER
SECTION
(Page 16)
C
2Vp-p
KEY MATRIX
LSW905-911,913,916-920
S901-906
KEY 1
32.768kHz
16.9344MHz
29 KEY 0
DI
64 DATA
CL
63 CLK
CE
62 CE
30 KEY 1
wd
IC1
SEG4 4
|
I
SEG49 49
(XTAL)
ts
8.38MHz
IC801
(PACK)
2.5Vp-p
10.25MHz
IC1
uj
IC601
(RFO)
4
BATT
X802
32.768kHz
37 XT2
38 XT1
X2 40
X1 41
X801
8.38MHz
(X2)
1.2Vp-p
1 VCC
LED901,902,904-909
LSW905-911,913,914,916-920
KEY
ILLUMINATION
(
0V
)
Approx. 100mVp-p
IC1
ILL B+
SWITCH
Q915
r;
3
2 OUT
ILL POWER
CONTROL
Q914
3Vp-p
3.2msec
IC1
REMOTE CONTROL
RECEIVER
IC951
ILL B+
(XT2)
2
3
SIRCS 44
ej
5Vp-p
COM1 52
|
I
COM4 55
43 KEY ACK
IC801
2
LCD
LCD901
ILL ON 48
5Vp-p
LCD DRIVER
IC901
SYSTEM CONTROL
IC801 (3/3)
KEY 0
1
1
LCD DO
LCD CLK
LCD CE
BACK
( LCDLIGHT
)
oa
(FEO)
5
LED910,911
0V
Approx. 100mVp-p
IC1
17
17
od
(TEO)
1
(XO)
CDX-L410X
3-6. PRINTED WIRING BOARDS — CD MECHANISM SECTION — • Refer to page 14 for Circuit Boards Location.
14
13
12
11
10
9
8
7
6
5
4
3
2
1
CN
2
A
C
THIS NOTE IS COMMON FOR PRINTED WIRING
BOARDS AND SCHEMATIC DIAGRAMS.
(In addition to this, the necessary note is
printed in each block.)
for schematic diagram:
• All capacitors are in µF unless otherwise noted. pF: µµF
50 WV or less are not indicated except for electrolytics
and tantalums.
• All resistors are in Ω and 1/4 W or less unless otherwise
specified.
•
%
: indicates tolerance.
f
•
: internal component.
• C : panel designation.
Note:
Note:
The components identi- Les composants identifiés par
fied by mark 0 or dotted une marque 0 sont critiques
line with mark 0 are criti- pour la sécurité.
Ne les remplacer que par une
cal for safety.
Replace only with part piéce portant le numéro
spécifié.
number specified.
D
E
• A : B+ Line.
• Power voltage is dc 14.4V and fed with regulated dc power
supply from ACC and BATT cords.
• Voltages are taken with a VOM (Input impedance 10 MΩ).
Voltage variations may be noted due to normal production tolerances.
• Waveforms are taken with a oscilloscope.
Voltage variations may be noted due to normal production tolerances.
• Circled numbers refer to waveforms.
• Signal path.
F : FM
f : AM
J : CD
F
G
for printed wiring boards:
• X : parts extracted from the component side.
• Y : parts extracted from the conductor side.
•
x
: parts mounted on the conductor side.
a
•
: Through hole.
•
: Pattern from the side which enables seeing.
(The other layer’s patterns are not indicated.)
Caution:
Pattern face side:
(Side B)
Parts face side:
(Side A)
B
H
I
Parts on the pattern face side seen from the
pattern face are indicated.
Parts on the parts face side seen from the
parts face are indicated.
J
18
18
CDX-L410X
1
2
3
4
5
6
7
8
9
10
11
12
13
14
A
TP63
R30
C5
C1
B
TP78
TP77
TP7
TP62
TP82
C4
R29
TP48
C43
TP59
CN1
TP71
TP70
C40
R5
R8
C24
TP22
TP24
TP25
C25
TP23
R19
IC1
C34 C45
C27
TP61
R9
C41
R17
C20
C19
C17
FB1
TP72
TP58
E
C16
R18
TP56
TP89
TP76
TP74
(Page 21)
SW2
TP88
C29
R21
D
C15
C8
TP51
SW5
TP10
C10
C23
C9
C18 C13
TP8
TP52
SW3
TP12
C11
R22
TP64
TP83
TP81
TP11
C14
TP50
TP47
TP9
R26
R3
TP60
C6
C
TP79 C3
TP80
TP66
TP84
Q1
TP69
X1
TP68
C35
TP46
C38
TP92
C26
TP45
TP37
TP41
TP39 TP40
C44
R20
TP35
TP34
TP36
TP49
TP57
F
C36
TP38
TP75
SW4
TP44
TP43
TP42
TP18
TP21
TP85
TP55
TP30
TP32
TP73
TP6
R7
R10 R12
R15
TP53
TP91
TP86
C22
TP87
IC2
TP26
TP4
TP29
TP19
C30
TP20
TP54
TP5
C37
C21
H
TP90
R14
G
TP28
TP17 TP16
TP27
I
TP3
TP2
CN3
TP1
J
19
19
CDX-L410X
• Refer to page 17 for Waveforms.
3-7. SCHEMATIC DIAGRAM — CD MECHANISM SECTION — • Refer to page 26 for IC Block Diagrams.
CN2
TP8
C20
C19
TP77
R29
TP78
R30
R3
R26
C23
C24
R9
C5
C43
C6
TP89
TP79
TP80
C35
R8
C1
C4
TP22
C18
C3
TP88
TP9
TP23
TP24
TP25
Q1
C14
TP81
TP82
TP45
TP10
TP83
TP84
C13
TP44
TP43
C11
TP42
TP41
R5
TP40
TP39
TP38
TP37
SW4
TP7
C15
IC1
TP46
C10
TP36
C38
TP12 C9
TP11
CN13
CN3
C8
TP85
TP35
TP34
M902
C16
C36
M901
IC B/D
C44
C25
TP92
C29
CN1
C17
FB1
C40
X1
R18
C34
TP75
TP59
C45
C26
C27
C41
TP1
TP5
SW5
TP61
TP76
TP60
R19
R20
TP6
R17
TP74
TP58
TP73
TP57
TP72
TP56
TP71
TP55
TP70
TP54
TP69
TP4
TP2
SW2
TP53
TP68
TP30
TP32
(Page 22)
TP52
TP66
SW3
TP3
R7
R15
TP21
TP51
R12
R22
TP18
TP50
R14
TP64
TP49
R10
C22
IC2
R21
C21
TP90
C30
TP17
TP27
TP20
TP16
TP29
TP26
TP19
TP28
TP91
TP48
TP63
TP47
TP62
C37
IC B/D
TP87
M903
TP86
Note:
• Voltage is dc with respect to ground under no-signal
(detuned) condition.
no mark : CD PLAY
20
20
CDX-L410X
3-8. PRINTED WIRING BOARDS — MAIN SECTION — • Refer to page 14 for Circuit Boards Location.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
PJ401
A
C105
CNJ601
CNP901
JW46
JW47
JW35
C951
C952
JW33
C914
Q918
Q929
Q913
JW9
JW10
JR805 R817
JW11
JW13
JW12
JW15
JW14
D923
Q919
Q912
Q915
D913
Q914
R918
R917
R924
R925
R919
R926
R927
JW7
JW4
JW150
JW5
R928
C915
IC902
R920 C916
JW6
R850
JR801
R934
R937
C913
Q909
JR901
JW17
C806
R929
JR806
CNP801
(Page 24)
21
21
JW1
SW802
JW3
JW2
JW8
R824
C959
C804
C805
JW32
D901
D903
R906
R901
R909
R404
C701
C907
JW19
C801
JW18
C920
C846
JW62
R922
R936
C919
JW20
C802
D999
C909
Q920
R822
JW64
JW104
R814
R815
R923
JW107
D802
R855
JR802
X801
D930
R935
JW21
R951
R708
R706
R705
X802
Q906
Q905
JW24
JW23
R816
C853
C803
D932
JW105
R836
JW106
FMB4
R952
JR809
D810
D809
Q921
R953
JW67
R821
R908
TH901
JW59
IC801
C852
C809
R704
JW124
JW125
JW119
JW120
JW121
R835
JW30
D908
D909
R710
FMB3
JW66
JW34
JW57
D916
R807
R803
R802
Q834
JW25
JR804
R842
R811
R812
R709
JW118
R916
R913
JW16
JW99
JW100
R806
R615
Q604
C841
D803
R847
R801
Q833
JW26
L702
C807
R810
R833
JW22
JW61
JW65
D806
D808
D804
JW108
C705
JW60
JW68
R832
JW29
FB701
R707
CNP701
D807
JW109
J
R818
JW151
R857
C608
D805
R860
JW69
D907
Q910
C704
R711
R619
JR605
JW101
JW102
R610 C626
C624
Q606
C842
JW70
D931
C609
C621
L604
R617
R618
R616
JW110
JW111 C652
C623
C625
R819
JW72
D911 C902
JW122
R914
JW123
JW27
R809
R712
JW71
R856
X601
R605
Q603
JW113
Q605
JW112
JW114
R604
R628
JR814
C633
IC601
C618
C617
R609
C207
Q904
JW28
L701
C703
JW73
R612
R611
C631
C610
C611 R606
C612
C613
C619
C651
C615
C650
C680
R622
JR808
C209
R613 L603
C614
R607
JW74
C208
JR606
R112
JW117
JW116
JW115
R620
R808
Q902
Q903
R716
JW76
JW97
R608 C622
I
FB702
JW96
L901
JW31
C707
JW98
R601
JW153
JW77
R602
H
C432
R714
JW95
R603
JW58
C110
C706
C702
C211
JW79
JW78
C848
R907
Q911
C847
C210
C111
IC401
R614
D604
C627
C604
C620
R932
JW80
E
C606
R933
R931
JW75
JW38
JW37
JW36
C904
D919
R823
JW39
D934
JW154
R111
C605
F
C932
Q917
D402
JW40
Q916
R930
JW55
R410
Q401
Q402
JW81
C603
JW41
JW54
D915
C203
R401
R102
R116
JW92
JW52
JW53
D444
C905
D933
JW51
D917
C426
C960
C204
C215
C901
JW83
R408
C669
Q907
JW50
D918
R209
C961
JW90 R115
JW91 R103
JW93
JW94
TU601
D922
Q201
R210 Q202
Q102
R110
C103
R109
JW84
C106
L669
D
JW42
JW49
JW85
R207
C401
JR412
JW43
JW48
C113
L601
C637
C216
R205
R108
JW86
Q101
JW89
R106
IC101
C206
R407
R105
C104
JW87
JW88
CP601
C
R107
JR810
JR411
R114
C112
R208
F901
D920 D921
C407
G
JW44
R206
C931
B
JW45
C671
C205
C672
• Semiconductor Location
Ref. No.
Ref. No. Location
D402
D-6
IC601
(Page 19) D444
D-5
IC801
D604
E-2
IC902
D802
J-4
D803
I-3
Q101
D804
I-3
Q102
D805
I-2
Q201
D806
I-3
Q202
D807
I-2
Q401
D808
I-3
Q402
D809
E-10
Q603
D813
I-4
Q604
D901
D-9
Q605
D903
D-9
Q606
D907
E-10
Q833
D908
F-11
Q834
D909
F-10
Q902
D911
F-7
Q903
D913
H-10
Q904
D915
D-7
Q905
D916
D-6
Q906
D917
D-6
Q907
D918
D-6
Q909
D919
C-6
Q910
D920
B-7
Q911
D921
B-8
Q912
D922
C-6
Q913
D923
G-11
Q914
D930
F-11
Q915
D931
H-4
Q916
D932
H-4
Q917
D933
C-8
Q918
D934
D-8
Q919
D999
F-11
Q920
Q921
IC101
B-6
Q929
IC401
E-4
Location
G-3
H-7
I-10
C-3
C-3
C-4
C-4
D-5
D-6
H-2
H-4
H-2
H-3
E-10
E-10
E-9
E-8
E-10
F-10
F-10
C-11
H-9
F-8
E-8
H-10
H-9
H-9
H-11
C-8
D-8
G-10
G-11
G-10
F-10
G-10
CDX-L410X
3-9. SCHEMATIC DIAGRAM — MAIN SECTION (1/2) — • Refer to page 17 for Waveforms.
Q907
Q910
Q917
TH901
R914
D907
R835
18k
R916
C907
Q929
D909
D911
C902
Q833
R937
Q903
D908
Q904
(Page 23)
R931
R932
R832
Q834
Q918
R934
D809
R833
Q919
R930
R933
Q906
R913
Q916
Q911
Q921
C905
Q905
C951
C919
C952
D923
JR805
(Page 20)
C802
C852
R836
C847
X801
C804
X802
C803
C701
C801
R824
CNP701
L701
C702
R935 D999
R936
C909
FB702
R822
JR801
JR804
JR802
D810
R922
Q920
D930
R923
C703
R952
R953
C920
R815
L702
R821
R951
C704 FB701
R814
R842
C853
IC801
R817
Q912
Q909
R809
R917
R704
R707
C913
R705
D913
R706
JR809
Q913
D931
C914
R810
R712
C846
R918
D932
R711
R919
R710
JR901
CNP801
R811
R812
R847
C705
R801
R802
Q915
Q914
R709
R708
R855
(Page 23)
(Page 25)
R928
R929
R926
R927
R925
JR806
R924
R803
R860
R857
R856
R920
IC902
C807
SW802
R819
R818
R850
C809
C915
C916
JR814
C959
D808
D806
D807
D804
D805
D803
D802
JR808
R807
22
22
Note:
• Voltage is dc with
respect to ground
under no-signal
(detuned) condition.
no mark : FM
(
) : AM
<
> : CD PLAY
CDX-L410X
• Refer to page 17 for Waveform.
3-10. SCHEMATIC DIAGRAM — MAIN SECTION (2/2) — • Refer to page 26 for IC Block Diagrams.
CNP901
C901
D901
IC101
C401
C105
R105
JR411
Q101
D444
D922
D920
R106
Q102
R205
Q201
PJ401
C103
JR412
R108
C206
D921
R109
R107
R206
R401
R110
C205
C104
C671
C216
R410
D919
R207
R209
C672
C203
D917
CNJ601
C113
D402
Q401
CP601
JR810
R208
D918
D915
L901
Q202
C432
C112
R210 C204
C637
D916
TU601
R906
R404
Q402
L601
C669
Q902
C426
D903
R908
R901
Q603
Q605
C407
R618
L669
R616
R407
C960
R408
R617
C931
D933
1SR154-400TE-25
D934
C932
R909
R907
R615
C904
Q606
Q604
C842
C603
C841
C604
(Page 22)
IC B/D
L603
IC401
R112 R116
R115
R612
R806
IC B/D
R103
C215
IC601
R102
R611
C605
R606
R613
R823
C609
C611
C111
R111
C110
C210
C211
R714
C706
C612
C631
C208
C209
R603
C613
R619
R609 C619
C606
C207
C614
C633
R716
R602
C610
JR605
C707
R607
C615
R608
C617
R601
C618
C106
C621
JR606
C620
R620
C680
C626
R610
C625
C650
C622
L604
C624
X601
C651
R622
C623
R605
R604
C848
R628
R614
(Page 22)
D604
C627
C652
C608
Note:
• Voltage is dc with respect to ground under no-signal
(detuned) condition.
no mark : FM
(
) : AM
<
> : CD PLAY
23
23
CDX-L410X
3-11. PRINTED WIRING BOARD — DISPLAY SECTION — • Refer to page 14 for Circuit Boards Location.
2
LED906
4
5
6
7
8
9
10
11
12
LED907
A
3
S901
13
14
LED908
LED909
1
LSW905
LED911
LED910
LED905
LSW906
LSW914
S903
LED904
LED902
LSW916
LSW917
LSW919
LSW918
D
LSW920
LSW911
LSW910
LSW908
S904
LSW909
S905
LSW907
C
LED901
IC951
B
LSW913
S902
S906
(Page 21)
D902
D903
D904
R957
C953
R958
R960
R959
R956
R975
R954
R953
C952
R955
E
CN901
G
R978
R986
R980
R976
R952
R969
R968
R979
R982
R915
FMB4
R967
R916
R903
R902
R905
R904
R906
R907
R966
R918
R951
D905
IC901
R974
FMB3
R961
R917
C951
R919
R909
R972
R973
R910
F
D951
R985
R908
R914
R912
C954
R977
R983
R981
H
• Semiconductor Location
Ref. No.
D902
D903
D904
D905
D951
Location
F-10
F-9
F-9
F-9
F-9
IC901
IC951
F-7
D-13
LED901
C-12
Ref. No.
LED902
LED904
LED905
LED906
LED907
LED908
LED909
LED910
LED911
Location
C-12
C-2
C-3
A-2
A-2
A-13
A-12
C-4
C-11
24
24
R913
R901
CDX-L410X
3-12. SCHEMATIC DIAGRAM — DISPLAY SECTION —
R972
R966
R974
R976
R986
R980
R982
R978
R967
LSW910(1/2)
CN901
LSW918(1/2)
LSW914(2/2)
LSW917(1/2)
LSW906(2/2)
IC951
R952
LSW909(1/2)
LSW919(1/2)
LED904
LSW916(1/2)
LSW913(2/2)
LSW905(2/2)
D951
LED910
R951
LED911
C951
(Page 22)
LSW908(1/2)
LED902
LSW920(1/2)
LED908
LED906
LED905
R958
R968
LED901
LSW911(1/2)
LED909
R960
LED907
R957
C953
R953
C952
D904
D903
LSW907(1/2)
D902
IC901
R959
R969
R973
R975
R985
R977
R981
R983
R979
R954
R955
R956
R961
D905
LSW913(1/2)
S902
S903
R901
R912
LSW914(1/2)
S904
R902
R913
S906
S905
R903
S901
R904
R915
LSW917(2/2)
LSW905(1/2)
R905
R916
LSW918(2/2)
LSW906(1/2)
R906
R917
LSW919(2/2)
LSW907(2/2)
R907
R918
LSW920(2/2)
LSW908(2/2)
R908
R919
LSW909(2/2)
R909
LSW910(2/2)
R910
R914
LSW916(2/2)
LCD901
LSW911(2/2)
Note:
• Voltage is dc with respect to ground under no-signal
(detuned) condition.
no mark : FM
25
25
CDX-L410X
3-13. IC BLOCK DIAGRAMS
SD
TD
FD
AGND
ATEST
TEST1
TEST0
DGND
TSTB
TSCK
TSI
TSO
PACK
DVDD
66
65
64
63
62
61
60
59
58
57
56
55
54
53
52
51
COMPARATOR
CD-TEXT DECODER
D/A
FD/TD/SD/MD
CONTROLLER
PS
4
IN1
5
IN2
6
PREVCC
(PRE.LOADING)
POWVCC12
(CH1.CH2)
42 RFCK
TIMING GENERATOR
ROM
DECODER
SVROM
40 DVDD
EFM
TEO 93
FEO
TEC 95
DE-EMPHASIS CIRCUIT
TRACKING
REGISTER
FOCUS
REGISTER
TEO
AGND 96
OCTUPLED
OVERSAMPLING DIGITAL FILTER
COMPARATOR
PD 97
NOISE SHAVER
–
VO2– 11
36 TX
VO2+ 12
–
VO1– 13
–
LEVEL
SHIFT
10k
10k
10k
–
VO1+ 14
–
LEVEL
SHIFT
LEVEL
SHIFT
–
10k
10k
10k
10k
18 VO3–
17 VO3+
10k
10k
10k
33 LRCKIN
32 SCKO
LEVEL
SHIFT
–
10k
34 LRCK
10k
10k
10k
+
MIRR
TE2 94
RFENV
MIRENV
37 DGND
35 HOLD/WDCK
OUTPUT PROCESSOR
A3T
21 MUTE
19 GND
+
A/D CONVERTER
FOK
TE- 92
D/A
INTERFACE
CIRCUIT
CH1-4
MUTE
VOL+ 10
+
DIGITAL
AUDIO
INTERFACE
DEFECT
COMPARATOR
DEFECT
+
POWVCC34
(CH3,CH4)
+
FE- 90
9
38 C16M
SWITCH
FEO 91
VOL–
+
20 POWVCC
39 TSOI
CLV
PROCESSOR
REFOUT 89
8
22 OPOUT3
41 LOCK
F 86
AVDD 88
POWVCC
+
10k
+
RF
AMP BLOCK
SVCRAM
+
–
MULTIPLIER
B 84
E 87
7
43 MIRR/WFCK
SVDRAM
TEOFS
D 85
PREVCC
44 PLCK
24 OPIN3+
23 OPIN3–
–
16k
C 83
DIGITAL PLL
EFM DEMODULATOR
25 OPOUT4
–
ADDER
FEOFS
POWER
SAVE
47 C1D2
45 DGND
A 82
X3
48 C2D1
46 C1D1
AGND 81
3
27 OPIN4+
26 OPIN4–
–
+
AUTO GAIN
CONTROLLER
RF- 80
SUB-CODE PROCESSOR
16K
SRAM
MEMORY
PROCESSOR
LDCONT
LOADING PRE
FWD REV
+
EQ1 79
2
16 VO4–
15 VO4+
–
EFM
49 C2D2
REV
28 BIAS
–
EQ2 78
50 C2D3
ERROR
CORRECTION
PROCESSOR
EFM
RFO 77
1
+
AGCI 76
MICROCOMPUTER INTERFACE
FWD
+
MD
67
+
7F DAC0
68
16k
7C DAC1
69
16k
7D DAC2
70
7.5k
7E DAC3
71
7.5k
AVDD
72
7.5k
EFM
73
–
ASY
74
16k
C3T
75
7.5k
RFI
IC2 BA5810FP-E2 (SERVO Board)
AGCO
IC1 µPD63711GC-8EU (SERVO Board)
10k
31 SCKIN
30 DOUT
29 DIN
NOISE SHAVER
LD 98
28 FLAG
OUTPUT BUFFER OUTPUT BUFFER
27 EMPH
PN 99
AVDD 100
MICROCOMPUTER INTERFACE
SCF
26 DVDD
OSC
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
RFOK
RST
A0
STB
SCK
SO
SI
XTALEN
DVDD
DAVDD
ROUT
DAGND
REGC
DAGND
LOUT
DAVDD
R+
R–
L–
L+
XVDD
XTAL
XTAL
XGND
XO
1
OSC
2
OSCILLATOR
BUFFER
24 XI
23 A-GND
22 REG
REGULATOR
ON/OFF
REFERENCE
DIVIDER
SEEK/RECP
21 VCC
VCC
20 AM_CP
–
+
5
3
4
5
6
SR
7
SERIAL
INTERFACE
SEEK/RECP
18 FM_CP
17 D-GND
18BIT
12BIT
PROGRAMMABLE
COUNTER
18BIT
19 VT
PRESCALLER
4BIT SWALLOW
COUNTER
+
CE
D_IN
CK
D_OUT
PHASE
COMPARATOR
+
40BIT SHIFT
REGISTER
+
4
REF
3
SIG
2
–
1
DGND
IC601 TB2118F-EL-S (MAIN Board)
LCL
8
I/O-2
9
SEEK 10
MONO 11
VDD2 12
26
26
AMP
AMP
I/O
PORT
VDD2
15 FM_VCO
VDD
22BIT
OUTPUT
PORT
20BIT
IF COUNTER
AMP
16 AM_VCO
14 VDD
13 IFC
CDX-L410X
IC401 BD3803F (MAIN Board)
DGND
28
SDA
27
SCL
26
MUTE
25
SEL
24
ADJ
23
VCC
22
OUTF1
21
OUTR1 OUTF2
20
19
OUTR2
18
DS32
17
DS22
16
DS12
15
VCC
2
I C BUS
LOGIC
FADER
(0~-58,
-∞dB)
VCO
ON
FADER
(0~-58,
-∞dB)
FADER
(0~-58,
-∞dB)
OFF
ON
EFFECT(OFF,6dB
10dB,14dB)
FADER
(0~-58,
-∞dB)
OFF
EFFECT(OFF,6dB
10dB,14dB)
TONE
PASS
TONE
PASS
BASS,TRBLE,MIDDLE
(-15dB~+15dB,1dB STEP)
BASS,TRBLE,MIDDLE
(-15dB~+15dB,1dB STEP)
VOLUME
(+23~-79dB,-∞dB
1dB STEP)
VOLUME
(+23~-79dB,-∞dB
1dB STEP)
INPUT GAIN
(0~15dB,1dB STEP)
INPUT GAIN
(0~15dB,1dB STEP)
MUTE
MUTE
INPUT SELECTOR
(4 STEREO INCLUDE 1 ISOLATION INPUT)
VCC/2
1
AGND
2
FIL
3
AP1
4
AN
5
AP2
6
B1
7
B2
8
C1
9
C2
10
D1
11 12
13 14
D2 DS11 DS21 DS31
27
CDX-L410X
Ver 1.1
SECTION 4
EXPLODED VIEWS
NOTE:
• The mechanical parts with no reference
number in the exploded views are not supplied.
• Items marked “*” are not stocked since
they are seldom required for routine service.
Some delay should be anticipated
when ordering these items.
• -XX and -X mean standardized parts, so
they may have some difference from the
original one.
• Color Indication of Appearance Parts
Example :
KNOB, BALANCE (WHITE) ... (RED)
R
R
Parts Color Cabinet’s Color
• Accessories are given in the last of this
parts list.
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
Les composants identifiés par une
marque 0 sont critiques pour
la sécurité.
Ne les remplacer que par une piéce
portant le numéro spécifié.
4-1. CHASSIS SECTION
A
5
3
MG-393XC-121//K
#1
#1
4
#2
A
#2
6
#2
9
#2
#3
8
#2
not supplied
#2
10
7
not
supplied
TU601
6
2
F901
#1
#1
1
not supplied
#1
11
Ref. No.
Part No.
Description
1
2
3
* 4
5
3-231-472-01
X-3382-588-1
1-776-206-21
3-024-285-01
3-246-007-01
SCREW (+B 2X4)
LOCK ASSY (S)
CORD (WITH CONNECTOR) (POWER)
CUSHION (RUBBER)
BRACKET (CD)
6
7
8
28
3-922-535-11 SCREW (+BTT)
A-3274-604-A MAIN BOARD, COMPLETE
3-041-261-11 BRACKET (TR)
Remark
Ref. No.
Part No.
Description
9
* 10
11
F901
TU601
A-3274-647-A
3-019-565-01
X-3382-622-1
1-532-877-11
A-3220-835-A
SPEAKER BOARD, COMPLETE
BRACKET (IC)
PANEL (1) ASSY, SUB
FUSE (BLADE TYPE) (AUTO FUSE) 10A
TUNER UNIT (TUX-010)
#1
#2
#3
7-685-792-09 SCREW +PTT 2.6X6 (S)
7-685-793-09 SCREW +PTT 2.6X8 (S)
7-685-795-09 SCREW +PTT 2.6X12 (S)
Remark
CDX-L410X
4-2. FRONT PANEL SECTION
57
58
#4
59
LCD901
#4
not supplied
56
not supplied
55
54
not supplied
(DISPLAY board)
not supplied
not supplied
52
54
not supplied
51
53
not supplied
Ref. No.
Part No.
Description
51
52
53
54
55
X-3382-620-1
X-3382-918-1
3-245-998-01
3-246-002-01
3-246-211-01
PANEL SUB ASSY, FRONT
BUTTON ASSY (S)
FILTER (IR)
PLATE (CD), LIGHT GUIDE
SPRING (RELEASE)
56
3-246-003-01 PANEL, FRONT BACK
Remark
Ref. No.
57
58
59
LCD901
#4
Part No.
Description
X-3378-390-3
A-3315-941-A
1-694-988-11
1-805-079-11
7-685-106-19
CASE ASSY (for FRONT PANEL)
PANEL COMPLETE ASSY, FRONT
CONDUCTIVE BOARD, CONNECTION
DISPLAY PANEL, LIQUID CRYSTAL
SCREW +P 2X10 TYPE2 NON-SLIT
Remark
29
CDX-L410X
4-3. CD MECHANISM SECTION (1)
(MG-393XC-121//K)
102
#5
#5
104
103
107
109
101
#7
116
118
114
115
106
111
105
114
117
C
105
113
110
C
#6
M903
112
#7
#7
108
Ref. No.
Part No.
Description
101
102
103
104
105
1-683-283-11
3-040-039-03
3-040-038-01
3-040-050-01
3-040-022-01
IN SELF SW BOARD
CHASSIS (T)
SPRING (LR), TENSION
LEVER (L)
RETAINER (ROLLER), SHAFT
106
107
108
109
110
3-040-044-01
3-040-067-01
A-3301-980-A
3-040-037-01
3-040-040-03
ROLLER (S)
LEVER (R)
SHAFT ROLLER ASSY
GUIDE (DISC)
ARM (ROLLER)
111
A-3283-233-A SERVO BOARD, COMPLETE
30
Remark
Ref. No.
#5
Part No.
Description
112
113
114
115
116
3-221-779-02
3-040-034-01
3-040-042-01
3-043-880-01
3-044-206-11
BRACKET (MOTOR)
SPRING (RA), TENSION
WASHER
RING (RA), RETAINING
SCREW, SPECIAL
117
118
M903
#5
#6
1-683-284-11
1-685-337-11
A-3315-039-A
7-627-553-37
7-627-553-17
PICK-UP FLEXIBLE BOARD
LOAD SW BOARD
MOTOR SUB ASSY, LO (LOADING)
SCREW, PRECISION +P 2X3 TYPE3
SCREW, PRECISION +P 2X2 TYPE3
#7
7-628-253-00 SCREW, SPECIAL
Remark
CDX-L410X
4-4. CD MECHANISM SECTION (2)
(MG-393XC-121//K)
154
151
156
157
157
158
D
160
164
not supplied
162
153
155
163
161
D
159
152
152
152
Ref. No.
Part No.
Description
151
152
153
154
155
3-040-025-02
3-040-031-01
3-040-056-01
3-040-024-01
3-040-054-01
ARM, CHUCKING
DAMPER (T)
LEVER (D)
RETAINER (DISC)
WHEEL (LW), WORM
156
157
3-040-026-01 SPRING (CH), TENSION
3-040-032-01 SPRING (FL), COMPRESSION
Remark
Ref. No.
Part No.
Description
158
159
160
161
162
3-040-033-01
A-3307-422-A
3-040-059-01
3-040-057-01
3-040-058-01
SPRING (KF1), TENSION
CHASSIS (M) COMPLETE ASSY
SPRING (TR), TENSION
LEVER (LOCK)
GEAR (MDL)
163
164
3-040-052-01 WHEEL (U), WORM
3-040-051-02 LEVER (TR)
Remark
31
CDX-L410X
4-5. CD MECHANISM SECTION (3)
(MG-393XC-121//K)
201
M901
207
202
M902
203
208
#8
209
210
#5
204
205
206
209
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
Ref. No.
Part No.
Description
201
202
203
204
205
X-3378-480-1
3-040-029-01
3-040-045-01
3-040-194-01
A-3301-983-A
CHASSIS (OP) ASSY (including M901)
SPRING (SL), TORSION
BASE (DRIVING)
GEAR (MIDWAY)
SHAFT (FEED) ASSY
206
207
3-040-030-01 SPRING (FEED), PLATE
1-823-641-11 CABLE, FLEXIBLE FLAT (6 CORE)
32
Remark
Les composants identifiés par une
marque 0 sont critiques pour
la sécurité.
Ne les remplacer que par une piéce
portant le numéro spécifié.
Ref. No.
Part No.
Description
208
209
0 210
M902
#5
1-683-282-11
3-909-607-01
8-820-165-06
A-3301-985-A
7-627-553-37
SL SW BOARD
SCREW
OPTICAL PICK-UP KSS-721A/C-RP
MOTOR ASSY, SLED (SLED)
SCREW, PRECISION +P 2X3 TYPE3
#8
7-627-850-28 SCREW, PRECISION +P 1.4X3
Remark
CDX-L410X
SECTION 5
ELECTRICAL PARTS LIST
NOTE:
• Due to standardization, replacements in
the parts list may be different from the
parts specified in the diagrams or the
components used on the set.
• -XX and -X mean standardized parts, so
they may have some difference from the
original one.
• RESISTORS
All resistors are in ohms.
METAL:Metal-film resistor.
METAL OXIDE: Metal oxide-film resistor.
F:nonflammable
• Items marked “*” are not stocked since
they are seldom required for routine service.
Some delay should be anticipated
when ordering these items.
• SEMICONDUCTORS
In each case, u : µ, for example:
uA.. : µA.. uPA.. : µPA..
uPB.. : µPB.. uPC.. : µPC.. uPD.. : µPD..
• CAPACITORS
uF : µF
• COILS
uH : µH
DISPLAY
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
Les composants identifiés par une
marque 0 sont critiques pour
la sécurité.
Ne les remplacer que par une piéce
portant le numéro spécifié.
When indicating parts by reference
number, please include the board.
Ref. No.
Part No.
Description
Remark
1-694-988-11 CONDUCTIVE BOARD, CONNECTION
< CAPACITOR >
1-164-227-11 CERAMIC CHIP
1-125-891-11 CERAMIC CHIP
1-162-927-11 CERAMIC CHIP
0.022uF
0.47uF
100PF
10%
10%
5%
25V
10V
50V
< CONNECTOR >
CN901
8-719-978-33
8-719-978-33
8-719-978-33
8-719-988-61
8-719-069-54
DIODE
DIODE
DIODE
DIODE
DIODE
DTZ-TT11-6.8B
DTZ-TT11-6.8B
DTZ-TT11-6.8B
1SS355TE-17
UDZS-TE-17-5.1B
< IC >
IC901
IC951
LSW917
LSW918
LSW919
LSW920
1-771-883-11
1-771-883-11
1-771-883-11
1-771-883-11
Description
Remark
6-702-852-01 IC LC75824W-E
8-749-017-35 IC KSM-401N
< LIQUID CRYSTAL DISPLAY >
LCD901 1-805-079-11 DISPLAY PANEL, LIQUID CRYSTAL
SWITCH, TACTILE (WITH LED) (BTM)
SWITCH, TACTILE (WITH LED) (6)
SWITCH, TACTILE (WITH LED) (5)
SWITCH, TACTILE (WITH LED) (4/SHUF)
< RESISTOR >
1-794-312-21 PIN, CONNECTOR 12P
< DIODE >
D902
D903
D904
D905
D951
Part No.
LSW910 1-771-883-11 SWITCH, TACTILE (WITH LED) (2)
LSW911 1-771-883-11 SWITCH, TACTILE (WITH LED) (3/REP)
LSW913 1-771-476-11 SWITCH, KEYBOARD (WITH LED)
(SEEK + L J)
LSW914 1-771-476-11 SWITCH, KEYBOARD (WITH LED)
(SEEK j l –)
LSW916 1-771-883-11 SWITCH, TACTILE (WITH LED) (DSPL)
DISPLAY BOARD
**************
C951
C952
C953
Ref. No.
R901
R902
R903
R904
R905
1-216-819-11
1-216-819-11
1-216-819-11
1-216-821-11
1-218-851-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
RES-CHIP
680
680
680
1K
1.5K
5%
5%
5%
5%
2%
1/10W
1/10W
1/10W
1/10W
1/16W
R906
R907
R908
R909
R910
1-218-851-11
1-216-825-11
1-216-827-11
1-216-829-11
1-218-867-11
RES-CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1.5K
2.2K
3.3K
4.7K
6.8K
2%
5%
5%
5%
5%
1/16W
1/10W
1/10W
1/10W
1/10W
R912
R913
R914
R915
R916
1-216-819-11
1-216-819-11
1-216-819-11
1-216-821-11
1-218-851-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
RES-CHIP
680
680
680
1K
1.5K
5%
5%
5%
5%
2%
1/10W
1/10W
1/10W
1/10W
1/16W
R917
R918
R919
R951
R952
1-218-851-11
1-216-825-11
1-216-827-11
1-216-815-11
1-216-825-11
RES-CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1.5K
2.2K
3.3K
330
2.2K
2%
5%
5%
5%
5%
1/16W
1/10W
1/10W
1/10W
1/10W
R953
R954
R955
R956
R957
1-216-821-11
1-216-821-11
1-216-821-11
1-216-821-11
1-216-850-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
1K
1K
270K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R958
R959
R960
R961
R966
1-216-821-11
1-216-821-11
1-216-821-11
1-216-857-11
1-216-815-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
1K
1M
330
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R967
R968
1-216-815-11 METAL CHIP
1-216-815-11 METAL CHIP
330
330
5%
5%
1/10W
1/10W
< DIODE >
LED901
LED902
LED904
LED905
LED906
8-719-053-09
8-719-053-09
8-719-053-09
8-719-053-09
8-719-053-09
LED
LED
LED
LED
LED
SML-310VTT86 (OFF)
SML-310VTT86 (EQ3)
SML-310VTT86 (SOURCE)
SML-310VTT86 (MODE)
SML-310VTT86 (SEL)
LED907
LED908
LED909
LED910
LED911
8-719-082-38
8-719-053-09
8-719-082-38
6-500-459-01
6-500-459-01
LED
LED
LED
LED
LED
CL-270SR-C-TS (GUIDE)
SML-310VTT86 (A)
CL-270SR-C-TS (GUIDE)
NSCW505T-ARS (LCD BACK LIGHT)
NSCW505T-ARS (LCD BACK LIGHT)
< SWITCH >
LSW905
LSW906
LSW907
LSW908
LSW909
1-771-476-11
1-771-476-11
1-771-883-11
1-771-883-11
1-771-883-11
SWITCH, KEYBOARD (WITH LED) (VOL +)
SWITCH, KEYBOARD (WITH LED) (VOL –)
SWITCH, TACTILE (WITH LED) (ATT)
SWITCH, TACTILE (WITH LED) (SENS)
SWITCH, TACTILE (WITH LED) (1)
33
CDX-L410X
DISPLAY
Ref. No.
IN SELF SW
LOAD SW
Remark
MAIN
Part No.
Description
Part No.
Description
R969
R972
R973
R974
R975
1-216-815-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
330
100
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
C205
C206
C207
C208
C209
1-162-964-11
1-164-346-11
1-125-891-11
1-115-467-11
1-115-467-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.001uF
1uF
0.47uF
0.22uF
0.22uF
10%
R976
R977
R978
R979
R980
1-216-813-11
1-216-813-11
1-216-813-11
1-216-813-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
220
220
220
220
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
C210
C211
C215
C216
C401
1-125-837-11
1-125-837-11
1-126-964-11
1-164-346-11
1-126-163-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
1uF
1uF
10uF
1uF
4.7uF
10%
10%
20%
20%
6.3V
6.3V
50V
16V
50V
R981
R982
R983
R985
R986
1-216-809-11
1-216-809-11
1-216-809-11
1-216-813-11
1-216-813-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
220
220
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
C407
C426
C432
C603
C604
1-126-964-11
1-162-964-11
1-124-589-11
1-164-227-11
1-162-970-11
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
10uF
0.001uF
47uF
0.022uF
0.01uF
20%
10%
20%
10%
10%
50V
50V
16V
25V
25V
C605
C606
C608
C609
C610
1-104-665-11
1-126-947-11
1-164-156-11
1-162-970-11
1-126-964-11
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT
100uF
47uF
0.1uF
0.01uF
10uF
20%
20%
10%
20%
10V
10V
25V
25V
50V
C611
C612
C613
C614
C615
1-162-927-11
1-162-927-11
1-162-927-11
1-164-174-11
1-165-176-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100PF
100PF
100PF
0.0082uF
0.047uF
5%
5%
5%
10%
10%
50V
50V
50V
25V
16V
C617
C618
C619
C620
C621
1-165-176-11
1-162-964-11
1-162-964-11
1-104-665-11
1-104-396-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
0.047uF
0.001uF
0.001uF
100uF
10uF
10%
10%
10%
20%
20%
16V
50V
50V
10V
16V
C622
C623
C624
C625
C626
1-162-911-11
1-162-912-11
1-162-915-11
1-162-963-11
1-164-315-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
6PF
7PF
10PF
680PF
470PF
0.5PF
0.5PF
0.5PF
10%
5%
50V
50V
50V
50V
50V
C627
C631
C633
C637
C650
1-164-156-11
1-126-964-11
1-162-964-11
1-216-295-11
1-164-245-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
SHORT CHIP
CERAMIC CHIP
0.1uF
10uF
0.001uF
0
0.015uF
20%
10%
25V
50V
50V
10%
25V
C651
C652
C669
C671
C672
1-164-245-11
1-164-227-11
1-162-919-11
1-162-970-11
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.015uF
0.022uF
22PF
0.01uF
0.01uF
10%
10%
5%
10%
10%
25V
25V
50V
25V
25V
C680
C701
C702
C703
C704
1-162-970-11
1-124-584-00
1-124-584-00
1-124-584-00
1-124-584-00
CERAMIC CHIP
ELECT
ELECT
ELECT
ELECT
0.01uF
100uF
100uF
100uF
100uF
10%
20%
20%
20%
20%
25V
10V
10V
10V
10V
C705
C706
C707
C801
C802
1-162-964-11
1-162-964-11
1-162-964-11
1-124-229-00
1-164-156-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
0.001uF
0.001uF
0.001uF
33uF
0.1uF
10%
10%
10%
20%
50V
50V
50V
10V
25V
C803
C804
C807
1-162-918-11 CERAMIC CHIP
1-164-160-11 CERAMIC CHIP
1-115-156-11 CERAMIC CHIP
18PF
20PF
1uF
5%
5%
50V
50V
10V
< SWITCH >
S901
S902
S903
S904
S905
1-771-884-11
1-771-884-11
1-771-884-11
1-771-884-11
1-771-884-11
SWITCH, TACTILE (WITH LED) (SEL)
SWITCH, TACTILE (WITH LED) (A)
SWITCH, TACTILE (WITH LED) (OFF)
SWITCH, TACTILE (WITH LED) (SOURCE)
SWITCH, TACTILE (WITH LED) (MODE)
S906
1-771-884-11 SWITCH, TACTILE (WITH LED) (EQ3)
*************************************************************
1-683-283-11 IN SELF SW BOARD
****************
< SWITCH >
SW2
1-529-566-31 SWITCH, PUSH (1 KEY) (SELF)
SW3
1-529-566-31 SWITCH, PUSH (1 KEY) (DISC IN)
*************************************************************
1-685-337-11 LOAD SW BOARD
***************
Ref. No.
Remark
10%
10%
10%
50V
16V
10V
10V
10V
< SWITCH >
SW5
1-529-566-31 SWITCH, PUSH (1 KEY) (DOWN)
*************************************************************
A-3274-604-A MAIN BOARD, COMPLETE (including
SPEAKER BOARD, COMPLETE)
*********************
3-019-565-01
3-041-261-11
7-685-793-09
7-685-795-09
*
BRACKET (IC)
BRACKET (TR)
SCREW +PTT 2.6X8 (S)
SCREW +PTT 2.6X12 (S)
< CAPACITOR >
C103
C104
C105
C106
C110
1-124-259-11
1-124-259-11
1-162-964-11
1-107-826-11
1-164-360-11
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
4.7uF
4.7uF
0.001uF
0.1uF
0.1uF
20%
20%
10%
10%
16V
16V
50V
16V
16V
C111
C112
C113
C203
C204
1-124-589-11
1-164-346-11
1-164-346-11
1-124-259-11
1-124-259-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
47uF
1uF
1uF
4.7uF
4.7uF
20%
16V
16V
16V
16V
16V
34
20%
20%
CDX-L410X
MAIN
Ref. No.
Part No.
Description
C809
C841
C842
C846
C847
1-164-156-11
1-162-964-11
1-162-964-11
1-162-964-11
1-115-156-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
C848
C852
C853
C901
C902
1-162-964-11
1-469-144-21
1-162-970-11
1-135-473-21
1-164-156-11
C904
C905
C907
C909
C913
Remark
Part No.
Description
10%
10%
10%
25V
50V
50V
50V
10V
D915
D916
D917
D918
D919
8-719-200-82
8-719-200-82
8-719-200-82
8-719-200-82
8-719-200-82
DIODE
DIODE
DIODE
DIODE
DIODE
11ES2
11ES2
11ES2
11ES2
11ES2
CERAMIC CHIP 0.001uF
FERRITE, EMI (SMD)
CERAMIC CHIP 0.01uF
ELECT
3300uF
CERAMIC CHIP 0.1uF
10%
50V
10%
20%
25V
16V
25V
D920
D921
D922
D923
D930
8-719-053-18
8-719-053-18
8-719-200-82
8-719-110-14
8-719-109-89
DIODE
DIODE
DIODE
DIODE
DIODE
1SR154-400TE-25
1SR154-400TE-25
11ES2
RD9.1ES-B3
RD5.6ES-B2
1-126-160-11
1-164-156-11
1-162-970-11
1-164-156-11
1-164-156-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
1uF
0.1uF
0.01uF
0.1uF
0.1uF
20%
50V
25V
25V
25V
25V
D931
D932
D933
D934
D999
8-719-988-61
8-719-988-61
8-719-053-18
8-719-200-82
8-719-991-33
DIODE
DIODE
DIODE
DIODE
DIODE
1SS355TE-17
1SS355TE-17
1SR154-400TE-25
11ES2
1SS133T-77
C914
C915
C916
C919
C920
1-104-665-11
1-110-654-11
1-164-156-11
1-124-229-00
1-124-584-00
ELECT
DOUBLE LAYERS
CERAMIC CHIP
ELECT
ELECT
100uF
0.047F
0.1uF
33uF
100uF
C931
C932
C951
C952
C959
1-164-156-11
1-162-964-11
1-162-964-11
1-162-964-11
1-164-156-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.001uF
0.001uF
0.001uF
0.1uF
10%
10%
10%
25V
50V
50V
50V
25V
C960
1-216-864-11 METAL CHIP
0
5%
1/10W
0.1uF
0.001uF
0.001uF
0.001uF
1uF
10%
20%
20%
20%
10V
5.5V
25V
10V
10V
Ref. No.
Remark
< FERRITE BEAD >
FB701
FB702
1-216-864-11 METAL CHIP
0
1-414-235-22 INDUCTOR, FERRITE BEAD
5%
1/10W
< IC >
IC101
IC401
IC601
IC801
IC902
8-759-827-12
6-703-302-01
8-759-586-59
6-802-552-01
8-759-837-07
IC
IC
IC
IC
IC
TA8272H
BD3803F-FE2
TB2118F-EL-S
uPD780076YGK-R23-9ET
S7139SF
< JUMPER RESISTOR >
< JACK >
CNJ601 1-793-598-11 JACK (ANTENNA)
< CONNECTOR >
CNP701 1-815-260-11 CONNECTOR, BOARD TO BOARD 30P
CNP801 1-794-311-21 PLUG, CONNECTOR 12P
CNP901 1-774-701-21 PIN, CONNECTOR 16P
< SURGE PROTECTOR >
CP601
JR411
JR412
JR605
JR606
JR801
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
0
0
0
0
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
JR802
JR804
JR805
JR806
JR808
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
0
0
0
0
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
JR809
JR810
JR814
JR901
1-216-864-11
1-216-295-11
1-216-864-11
1-216-864-11
METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
0
0
0
0
5%
1/10W
5%
5%
1/10W
1/10W
1-803-902-21 PROTECTOR CHIP, SURGE
< DIODE >
D402
D444
D604
D802
D803
8-719-988-61
8-719-988-61
8-719-109-85
8-719-978-33
8-719-109-97
DIODE
DIODE
DIODE
DIODE
DIODE
1SS355TE-17
1SS355TE-17
RD5.1ES-B2
DTZ-TT11-6.8B
RD6.8ES-B2
D804
D805
D806
D807
D808
8-719-978-33
8-719-978-33
8-719-109-97
8-719-109-97
8-719-109-97
DIODE
DIODE
DIODE
DIODE
DIODE
DTZ-TT11-6.8B
DTZ-TT11-6.8B
RD6.8ES-B2
RD6.8ES-B2
RD6.8ES-B2
D809
D813
D901
D903
D907
8-719-921-63
8-719-109-97
8-719-049-38
8-719-109-97
8-719-110-49
DIODE
DIODE
DIODE
DIODE
DIODE
MTZJ-7.5B
RD6.8ES-B2
1N5404TU
RD6.8ES-B2
RD18ES-B2
D908
D909
D911
8-719-921-63 DIODE MTZJ-7.5B
8-719-109-97 DIODE RD6.8ES-B2
8-719-109-89 DIODE RD5.6ES-B2
< COIL >
L601
L603
L604
L669
L701
1-410-508-11
1-412-006-31
1-410-750-41
1-424-759-21
1-410-513-11
INDUCTOR
INDUCTOR
INDUCTOR
COIL (AM ANT)
INDUCTOR
L702
L901
1-410-513-11 INDUCTOR
1-419-476-31 COIL, CHOKE
8.2uH
10uH
0.47uH
22uH
22uH
250uH
< JACK >
PJ401
1-774-698-11 JACK, PIN 2P (AUDIO OUT)
< TRANSISTOR >
Q101
Q102
8-729-920-21 TRANSISTOR DTC314TK-T-146
8-729-920-21 TRANSISTOR DTC314TK-T-146
35
CDX-L410X
MAIN
Ref. No.
Part No.
Description
Part No.
Description
Q201
Q202
Q401
Q402
Q603
8-729-920-21
8-729-920-21
8-729-055-92
8-729-055-96
8-729-030-51
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTC314TK-T-146
DTC314TK-T-146
SRA2203SF
SRC1203SF
2SA1515S-R-TP
Remark
R604
R605
R606
R607
R608
1-216-821-11
1-216-841-11
1-216-841-11
1-216-827-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
47K
47K
3.3K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
Q604
Q605
Q606
Q833
Q834
8-729-055-96
8-729-030-51
8-729-055-96
8-729-049-40
8-729-055-96
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
SRC1203SF
2SA1515S-R-TP
SRC1203SF
2SC5343SFG
SRC1203SF
R609
R610
R611
R612
R613
1-216-809-11
1-216-809-11
1-218-867-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
6.8K
10K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
Q902
Q903
Q904
Q905
Q906
8-729-049-40
8-729-055-96
8-729-055-96
8-729-055-96
8-729-055-92
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC5343SFG
SRC1203SF
SRC1203SF
SRC1203SF
SRA2203SF
R614
R615
R616
R617
R618
1-249-409-11
1-216-825-11
1-216-845-11
1-216-825-11
1-216-845-11
CARBON
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
220
2.2K
100K
2.2K
100K
5%
5%
5%
5%
5%
1/4W
1/10W
1/10W
1/10W
1/10W
Q907
Q909
Q910
Q911
Q912
8-729-021-82
8-729-055-96
8-729-920-85
8-729-055-96
8-729-055-92
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SD2396K
SRC1203SF
2SD1664-QR
SRC1203SF
SRA2203SF
R619
R620
R622
R628
R704
1-216-817-11
1-216-817-11
1-216-817-11
1-216-829-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
470
470
470
4.7K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
Q913
Q914
Q915
Q916
Q917
8-729-019-00
8-729-055-96
8-729-049-43
8-729-049-43
8-729-820-46
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SD2394-G
SRC1203SF
STB1132Y
STB1132Y
2SB1202FAS
R705
R706
R707
R708
R709
1-216-821-11
1-216-813-11
1-216-849-11
1-216-821-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
220
220K
1K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
Q918
Q919
Q920
Q921
Q929
8-729-055-92
8-729-920-85
8-729-920-85
8-729-055-96
8-729-055-96
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
SRA2203SF
2SD1664-QR
2SD1664-QR
SRC1203SF
SRC1203SF
R710
R711
R712
R714
R716
1-216-821-11
1-216-821-11
1-216-821-11
1-216-825-11
1-216-825-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
1K
2.2K
2.2K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R801
R802
R803
R806
R807
1-216-809-11
1-216-809-11
1-216-849-11
1-249-417-11
1-216-849-11
METAL CHIP
METAL CHIP
METAL CHIP
CARBON
METAL CHIP
100
100
220K
1K
220K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/4W
1/10W
R809
R810
R811
R812
R814
1-216-849-11
1-249-417-11
1-249-417-11
1-249-417-11
1-216-809-11
METAL CHIP
CARBON
CARBON
CARBON
METAL CHIP
220K
1K
1K
1K
100
5%
5%
5%
5%
5%
1/10W
1/4W
1/4W
1/4W
1/10W
R815
R817
R818
R819
R821
1-216-809-11
1-216-849-11
1-216-845-11
1-216-849-11
1-249-433-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
CARBON
100
220K
100K
220K
22K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/4W
R822
R823
R824
R832
R833
1-216-849-11
1-249-417-11
1-216-849-11
1-216-849-11
1-216-849-11
METAL CHIP
CARBON
METAL CHIP
METAL CHIP
METAL CHIP
220K
1K
220K
220K
220K
5%
5%
5%
5%
5%
1/10W
1/4W
1/10W
1/10W
1/10W
R835
R836
R842
R847
R850
1-216-836-11
1-249-425-11
1-216-821-11
1-216-809-11
1-216-845-11
METAL CHIP
CARBON
METAL CHIP
METAL CHIP
METAL CHIP
18K
4.7K
1K
100
100K
5%
5%
5%
5%
5%
1/10W
1/4W
1/10W
1/10W
1/10W
R855
R856
R857
1-216-821-11 METAL CHIP
1-249-409-11 CARBON
1-249-409-11 CARBON
1K
220
220
5%
5%
5%
1/10W
1/4W
1/4W
< RESISTOR >
R102
R103
R105
R106
R107
1-216-809-11
1-216-809-11
1-249-429-11
1-249-429-11
1-216-841-11
METAL CHIP
METAL CHIP
CARBON
CARBON
METAL CHIP
100
100
10K
10K
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/4W
1/4W
1/10W
R108
R109
R110
R111
R112
1-216-841-11
1-216-809-11
1-216-809-11
1-218-882-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
100
100
30K
100K
5%
5%
5%
0.5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R115
R116
R205
R206
R207
1-216-833-11
1-216-833-11
1-249-429-11
1-249-429-11
1-216-841-11
METAL CHIP
METAL CHIP
CARBON
CARBON
METAL CHIP
10K
10K
10K
10K
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/4W
1/4W
1/10W
R208
R209
R210
R401
R404
1-216-841-11
1-216-809-11
1-216-809-11
1-216-833-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
100
100
10K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R407
R408
R410
R601
R602
1-249-437-11
1-216-827-11
1-216-805-11
1-249-417-11
1-216-821-11
CARBON
METAL CHIP
METAL CHIP
CARBON
METAL CHIP
47K
3.3K
47
1K
1K
5%
5%
5%
5%
5%
1/4W
1/10W
1/10W
1/4W
1/10W
R603
1-249-407-11 CARBON
150
5%
1/4W
36
Ref. No.
Remark
CDX-L410X
MAIN
Ref. No.
SERVO
Part No.
Description
Remark
Ref. No.
Part No.
Description
R860
R901
R906
R907
R908
1-216-813-11
1-249-425-11
1-249-425-11
1-216-841-11
1-216-841-11
METAL CHIP
CARBON
CARBON
METAL CHIP
METAL CHIP
220
4.7K
4.7K
47K
47K
5%
5%
5%
5%
5%
1/10W
1/4W
1/4W
1/10W
1/10W
C6
C8
C9
C10
C11
1-162-970-11
1-107-826-11
1-162-924-11
1-162-924-11
1-162-909-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.1uF
56PF
56PF
4PF
10%
10%
5%
5%
0.25PF
25V
16V
50V
50V
50V
R909
R913
R914
R916
R917
1-216-828-11
1-249-417-11
1-216-821-11
1-249-413-11
1-249-409-11
METAL CHIP
CARBON
METAL CHIP
CARBON
CARBON
3.9K
1K
1K
470
220
5%
5%
5%
5%
5%
1/10W
1/4W
1/10W
1/4W
1/4W
C13
C14
C15
C16
C17
1-162-916-11
1-125-837-11
1-162-970-11
1-162-970-11
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
12PF
1uF
0.01uF
0.01uF
0.01uF
5%
10%
10%
10%
10%
50V
6.3V
25V
25V
25V
R918
R919
R920
R922
R923
1-216-845-11
1-249-421-11
1-216-849-11
1-208-806-11
1-208-806-11
METAL CHIP
CARBON
METAL CHIP
RES-CHIP
RES-CHIP
100K
2.2K
220K
10K
10K
5%
5%
5%
0.5%
0.5%
1/10W
1/4W
1/10W
1/10W
1/10W
C18
C19
C20
C21
C22
1-162-966-11
1-107-826-11
1-107-826-11
1-162-970-11
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.0022uF
0.1uF
0.1uF
0.01uF
0.01uF
10%
10%
10%
10%
10%
50V
16V
16V
25V
25V
R924
R925
R926
R927
R928
1-249-404-00
1-249-404-00
1-249-404-00
1-249-404-00
1-249-404-00
CARBON
CARBON
CARBON
CARBON
CARBON
82
82
82
82
82
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
C23
C24
C25
C26
C27
1-162-970-11
1-162-970-11
1-162-970-11
1-126-391-11
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
0.01uF
0.01uF
0.01uF
47uF
0.01uF
10%
10%
10%
20%
10%
25V
25V
25V
6.3V
25V
R929
R930
R931
R932
R933
1-249-404-00
1-216-845-11
1-249-421-11
1-249-421-11
1-216-821-11
CARBON
METAL CHIP
CARBON
CARBON
METAL CHIP
82
100K
2.2K
2.2K
1K
5%
5%
5%
5%
5%
1/4W
1/10W
1/4W
1/4W
1/10W
C29
C30
C34
C35
C36
1-162-970-11
1-162-970-11
1-162-970-11
1-162-970-11
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.01uF
0.01uF
0.01uF
0.01uF
10%
10%
10%
10%
10%
25V
25V
25V
25V
25V
R934
R935
R936
R937
R951
1-216-041-00
1-249-395-11
1-218-867-11
1-216-041-00
1-216-821-11
METAL CHIP
CARBON
METAL CHIP
METAL CHIP
METAL CHIP
470
15
6.8K
470
1K
5%
5%
5%
5%
5%
1/10W
1/4W
1/10W
1/10W
1/10W
C37
C38
C40
C41
C43
1-126-393-11
1-162-970-11
1-107-826-11
1-162-970-11
1-162-967-11
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
33uF
0.01uF
0.1uF
0.01uF
0.0033uF
20%
10%
10%
10%
10%
10V
25V
16V
25V
50V
R952
R953
1-216-809-11 METAL CHIP
1-216-809-11 METAL CHIP
100
100
5%
5%
1/10W
1/10W
C44
C45
1-125-837-11 CERAMIC CHIP
1-162-970-11 CERAMIC CHIP
1uF
0.01uF
10%
10%
6.3V
25V
< SWITCH >
SW802
Remark
< CONNECTOR >
1-762-638-21 SWITCH, TACTILE (RESET)
CN1
CN3
1-815-352-11 CONNECTOR, BOARD TO BOARD 30P
1-816-275-21 CONNECTOR, FFC/FPC 6P
< THERMISTOR >
< JUMPER RESISTOR >
TH901
1-809-148-11 THERMISTOR PTH8L07AR2R0M1B510
FB1
1-216-864-11 METAL CHIP
0
5%
1/10W
< TUNER >
< IC >
TU601
A-3220-835-A TUNER UNIT (TUX-010)
IC1
IC2
< VIBRATOR >
X601
1-781-246-21 VIBRATOR, CRYSTAL (10.25MHz)
X801
1-795-259-11 VIBRATOR, CERAMIC (8.38MHz)
X802
1-567-098-41 VIBRATOR, CRYSTAL (32kHz)
*************************************************************
8-759-699-98 IC uPD63711GC-8EU
8-759-658-87 IC BA5810FP-E2
< TRANSISTOR >
Q1
8-729-904-87 TRANSISTOR 2SB1197K-R
< RESISTOR >
A-3283-233-A SERVO BOARD, COMPLETE
**********************
1-683-284-11 PICK-UP FLEXIBLE BOARD
< CAPACITOR >
C1
C3
C4
C5
1-162-970-11
1-162-970-11
1-104-609-11
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
0.01uF
0.01uF
100uF
0.01uF
10%
10%
20%
10%
25V
25V
4V
25V
R3
R5
R7
R8
R9
1-216-797-11
1-218-344-11
1-216-839-11
1-216-833-11
1-216-840-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10
7.5K
33K
10K
39K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R10
R12
R14
R15
1-216-835-11
1-216-837-11
1-216-841-11
1-216-841-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
15K
22K
47K
47K
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
37
CDX-L410X
SERVO
Ref. No.
SL SW
SPEAKER
Part No.
Description
R17
R18
R19
R20
R21
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
100
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
Remark
R22
R26
R29
R30
1-216-821-11
1-216-797-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
10
10K
10K
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
Ref. No.
Part No.
Description
Remark
PARTS FOR INSTALLATION AND CONNECTIONS
***************************************
251
252
253
254
255
X-3382-647-1
3-934-325-01
3-246-009-01
1-776-206-21
3-246-471-01
FRAME ASSY, FITTING
SCREW (+K 5X8 TP)
COLLAR
CORD (WITH CONNECTOR) (POWER)
KEY (FRAME)
251
252
254
255
253
< VIBRATOR >
X1
1-795-520-11 VIBRATOR, CERAMIC (16.9344MHz)
*************************************************************
1-683-282-11 SL SW BOARD
************
< SWITCH >
SW4
1-529-565-41 SWITCH, PUSH (1 KEY) (LIMIT)
*************************************************************
A-3274-647-A SPEAKER BOARD, COMPLETE (supplied with
MAIN BOARD, COMPLETE)
************************
*************************************************************
MISCELLANEOUS
***************
3
201
207
0 210
F901
1-776-206-21
X-3378-480-1
1-823-641-11
8-820-165-06
1-532-877-11
CORD (WITH CONNECTOR) (POWER)
CHASSIS (OP) ASSY (including M901)
CABLE, FLEXIBLE FLAT (6 CORE)
OPTICAL PICK-UP KSS-721A/C-RP
FUSE (BLADE TYPE) (AUTO FUSE) 10A
M902
A-3301-985-A MOTOR ASSY, SLED (SLED)
M903
A-3315-039-A MOTOR SUB ASSY, LO (LOADING)
*************************************************************
ACCESSORIES
************
3-247-731-11 MANUAL, INSTRUCTION (ENGLISH,FRENCH)
3-247-732-11 MANUAL, INSTRUCTION, INSTALL (ENGLISH,
FRENCH)
X-3378-390-3 CASE ASSY (for FRONT PANEL)
*************************************************************
38
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
Les composants identifiés par une
marque 0 sont critiques pour
la sécurité.
Ne les remplacer que par une piéce
portant le numéro spécifié.
CDX-L410X
US Model
Canadian Model
SERVICE MANUAL
Ver 1.1 2003. 06
SUPPLEMENT-1
File this supplement with the service manual.
Subject : Change of optical pick-up block
The optical pick-up block have been changed in the process of production.
Confirm an optical pick-up block pattern name when you exchange optical pickup block.
Discrimination
KSS-721A
KSS-720A
9-874-230-81
1
CDX-L410X
Parts List
1
2
Ref. No.
Part No.
01
01
2
8-820-103-11 OPTICAL PICK-UP KSS-720A/C-RP
8-820-165-06 OPTICAL PICK-UP KSS-721A/C-RP
7-627-553-37 PRECISION SCREW +P 2X3 TYPE3
(for KSS-720A)
3-909-607-01 SCREW (for KSS-721A)
2
Description
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
2
Remark
Les composants identifiés par une
marque 0 sont critiques pour
la sécurité.
Ne les remplacer que par une piéce
portant le numéro spécifié.
CDX-L410X
MEMO
3
CDX-L410X
REVISION HISTORY
Clicking the version allows you to jump to the revised page.
Also, clicking the version at the upper on the revised page allows you to jump to the next revised page.
Ver.
1.0
1.1
4
Date
2002. 11
2003. 06
Description of Revision
New
addition of Ref. No. 11. Change of optical pick-up block.
(ENG-03005)