Download Sony CDX-CA400 User's Manual

CDX-CA400/CA530X/CA580X
SERVICE MANUAL
US Model
Canadian Model
Ver 1.0 2001. 12
CDX-CA400
E Model
CDX-CA530X/CA580X
Photo: CDX-CA400
• The tuner and CD sections have no adjustments.
AUDIO POWER SPECIFICATIONS (US Model)
POWER OUTPUT AND TOTAL HARMONIC DISTORTION
23 watts per channel minimum continuous average power into
4 ohms, 4 channels driven from 20 Hz to 20 kHz with no more
than 5% total harmonic distortion.
Model Name Using Similar Mechanism
CDX-L300/L460X
CD Drive Mechanism Type
MG-393XA-121//K
Optical Pick-up Name
KSS-720A
SPECIFICATIONS
CD player section
Signal-to-noise ratio
Frequency response
Wow and flutter
General
90 dB
10 – 20,000 Hz
Below measurable limit
Outputs
Tone controls
Tuner section
FM
Tuning range
Antenna terminal
Intermediate frequency
Usable sensitivity
Selectivity
Signal-to-noise ratio
87.5 – 107.9 MHz
External antenna connector
10.7 MHz
11 dBf
75 dB at 400 kHz
65 dB (stereo),
68 dB (mono)
Harmonic distortion at 1 kHz
0.7% (stereo),
0.5% (mono)
Separation
33 dB at 1 kHz
Frequency response
30 – 15,000 Hz
AM
Tuning range
Antenna terminal
Intermediate frequency
Sensitivity
530 – 1,710 kHz
External antenna connector
10.7 MHz/450 kHz
30 µV
Power requirements
Dimensions
Mounting dimensions
Mass
Supplied accessories
Audio outputs
Power antenna relay control lead
Power amplifier control lead
Bass ±10 dB at 20 Hz (CDX-CA400)
Bass ±9 dB at 100 Hz (CDX-CA530X/CA580X)
Treble ±10 dB at 20 kHz (CDX-CA400)
Treble ±9 dB at 10 kHz (CDX-CA530X/CA580X)
12 V DC car battery
(negative ground)
Approx. 178 × 50 × 177 mm
(7 1/8 × 2 × 7 in.) (w/h/d)
Approx. 182 × 53 × 161 mm
(7 1/4 × 2 1/8 × 6 3/8 in.) (w/h/d)
Approx. 1.2 kg
(2 lb. 10 oz.)
Parts for installation and connections (1 set)
Front panel case (1)
Card remote commander
RM-X115 (CA400/CA580X)
Note
This unit cannot be connected to a digital preamplifier or an equalizer.
Design and specifications are subject to change without
notice.
Power amplifier section
Outputs
Speaker outputs
(sure seal connectors)
Speaker impedance
4 – 8 ohms
Maximum power output 50 W × 4 (at 4 ohms)
FM/AM COMPACT DISC PLAYER
9-873-433-01
Sony Corporation
2001L0400-1
© 2001. 12
e Vehicle Company
Published by Sony Engineering Corporation
1
CDX-CA400/CA530X/CA580X
SERVICE NOTES
NOTES ON HANDLING THE OPTICAL PICK-UP BLOCK
OR BASE UNIT
The laser diode in the optical pick-up block may suffer electrostatic
breakdown because of the potential difference generated by the
charged electrostatic load, etc. on clothing and the human body.
During repair, pay attention to electrostatic breakdown and also use
the procedure in the printed matter which is included in the repair
parts.
The flexible board is easily damaged and should be handled with
care.
NOTES ON LASER DIODE EMISSION CHECK
The laser beam on this model is concentrated so as to be focused on
the disc reflective surface by the objective lens in the optical pickup block. Therefore, when checking the laser diode emission, observe from more than 30 cm away from the objective lens.
CAUTION
Use of controls or adjustments or performance of procedures
other than those specified herein may result in hazardous
radiation exposure.
If the optical pick-up block is defective, please replace the whole
optical pick-up block.
Never turn the semi-fixed resistor located at the side of optical
pick-up block.
optical pick-up block
Notes on Chip Component Replacement
• Never reuse a disconnected chip component.
• Notice that the minus side of a tantalum capacitor may be damaged by heat.
semi-fixed resistor
TEST DISCS
This set can playback CD-R and CD-ROM discs. The following
test discs should be used to check the capability:
CD-R test disc TCD-R082LMT (Part No. J-2501-063-1)
CD-RW test disc TCD-W082L (Part No. J-2501-063-2)
Notes on CD-R/CD-RW discs
• You can play CD-Rs (recordable CDs)/CD-RWs (rewritable CDs)
designed for audio use on this unit.
Look for these marks to distinguish CD-Rs/CD-RWs for audio
use.
These marks denote that a disc is not for audio use.
• Some CD-Rs/CD-RWs (depending on the equipment used for
its recording or the condition of the disc) may not play on this
unit.
• You cannot play a CD-R/CD-RW that is not finalized∗.
∗ A process necessary for a recorded CD-R/CD-RW disc to be
played on the audio CD player.
SAFETY-RELATED COMPONENT WARNING!!
ATTENTION AU COMPOSANT AYANT RAPPORT
À LA SÉCURITÉ!!
COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE
WITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN
THE PARTS LIST ARE CRITICAL TO SAFE OPERATION.
REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE
PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR
IN SUPPLEMENTS PUBLISHED BY SONY.
LES COMPOSANTS IDENTIFIÉS PAR UNE MARQUE 0 SUR LES
DIAGRAMMES SCHÉMATIQUES ET LA LISTE DES PIÈCES
SONT CRITIQUES POUR LA SÉCURITÉ DE FONCTIONNEMENT.
NE REMPLACER CES COMPOSANTS QUE PAR DES PIÈCES
SONY DONT LES NUMÉROS SONT DONNÉS DANS CE MANUEL
OU DANS LES SUPPLÉMENTS PUBLIÉS PAR SONY.
2
CDX-CA400/CA530X/CA580X
TABLE OF CONTENTS
3. DIAGRAMS
1. GENERAL
Location of controls (CDX-CA400) ........................................ 4
Location of controls (CDX-CA530X/CA580X) ..................... 4
Connections (CDX-CA400) .................................................... 5
Connections (CDX-CA530X/CA580X) .................................. 6
2. DISASSEMBLY
2-1. Panel (1) Assy, Sub ............................................................. 7
2-2. CD Mechanism Block ......................................................... 8
2-3. Main Board ......................................................................... 8
2-4. Heat Sink ............................................................................. 9
2-5. Chassis (T) Sub Assy .......................................................... 9
2-6. Lever Section .................................................................... 10
2-7. Servo Board ....................................................................... 10
2-8. Shaft Roller Assy .............................................................. 11
2-9. Floating Block Assy .......................................................... 11
2-10. Optical Pick-up Block ....................................................... 12
3-1. IC Pin Description ............................................................. 13
3-2. Block Diagram –CD Section– ........................................... 15
3-3. Block Diagram –Tuner Section– ....................................... 16
3-4. Block Diagram –Display Section– .................................... 17
3-5. Circuit Boards Location .................................................... 17
3-6. Printed Wiring Boards –CD Mechanism Section– ............ 18
3-7. Schematic Diagram –CD Mechanism Section– ................ 20
3-8. Printed Wiring Board –Main Section– .............................. 21
3-9. Schematic Diagram –Main Section (1/2)– ........................ 22
3-10. Schematic Diagram –Main Section (2/2)– ........................ 23
3-11. Printed Wiring Board –Display Section– .......................... 24
3-12. Schematic Diagram –Display Section– ............................. 25
4. EXPLODED VIEWS
4-1.
4-2.
4-3.
4-4.
4-5.
Chassis Section ................................................................. 28
Front panel Section ........................................................... 29
CD Mechanism Section (1) ............................................... 30
CD Mechanism Section (2) ............................................... 31
CD Mechanism Section (3) ............................................... 32
5. ELECTRICAL PARTS LIST ........................................ 33
EXTENSION CABLE AND SERVICE POSITION
When repairing or servicing this set, connect the jig (extension cable)
as shown below.
• Connect the MAIN board (CNP701) and the SERVO board (CN1)
with the extension cable (Part No. J-2502-062-1).
MAIN BOARD CNP701
SERVO BOARD CN1
3
CDX-CA400/CA530X/CA580X
SECTION 1
GENERAL
(CDX-CA400)
This section is extracted
from instruction manual.
(CDX-CA530X/CA580X)
(CDX-CA530X/CA580X)
(CDX-CA400)
4
CDX-CA400/CA530X/CA580X
Connections (CDX-CA400)
5
CDX-CA400/CA530X/CA580X
Connections (CDX-CA530X/CA580X)
6
CDX-CA400/CA530X/CA580X
SECTION 2
DISASSEMBLY
Note : This set can be disassemble according to the following sequence.
SET
2-5.
CHASSIS (T) SUB ASSY
(Page 9)
CD MECHANISM BLOCK
(Page 8)
2-6.
LEVER SECTION
(Page 10)
2-3.
MAIN BOARD
(Page 8)
2-8.
SHAFT ROLLER ASSY
(Page 11)
2-4.
HEAT SINK
(Page 9)
2-9.
FLOATING BLOCK ASSY
(Page 11)
2-10.
OPTICAL PICK-UP BLOCK
(Page 12)
2-1.
PANEL (1) ASSY, SUB
(Page 7)
2-2.
2-7.
SERVO BOARD
(Page 10)
Note : Follow the disassembly procedure in the numerical order given.
2-1. PANEL (1) ASSY, SUB
claws
3 claw
1 PTT 2.6x6
4 claws
2 PTT 2.6x6
5 panel (1) assy, sub
7
CDX-CA400/CA530X/CA580X
2-2. CD MECHANISM BLOCK
7 bracket (CD)
5 CD mechanism block
6 PTT 2.6x6
2 PTT 2.6x6
3
1 PTT 2.6x6
4 CNP701
2-3. MAIN BOARD
5 MAIN board
3 screw (+BTT)
4 screws (+BTT)
2 PTT 2.6x8
1 PTT 2.6x8
8
CDX-CA400/CA530X/CA580X
2-4. HEAT SINK
6 heat sink
5 PTT 2.6x8
4 PTT 2.6x8
3 PTT 2.6x12
2 PTT 2.6x8
1 PTT 2.6x8
2-5. CHASSIS (T) SUB ASSY
2 P 2x3
3 P 2x3
1 Unsolder the
lead wires.
4 chassis (T) sub assy
black
red
white
9
CDX-CA400/CA530X/CA580X
2-6. LEVER SECTION
5 guide (disc)
6 lever (R)
3 tension spring (LR)
7 lever (L)
1 special screw
2 IN SELF SW board
4 claws
2-7. SERVO BOARD
7 SERVO board
6 special screw
5 special screws
2 Removal the solders.
8 connector
1 CN3
3 P 2x3
4 loading motor assy
optical pick-up block
10
CDX-CA400/CA530X/CA580X
2-8. SHAFT ROLLER ASSY
• When installing, take note of the positions
arm (roller) and washers. (Fig. 1)
3 retaing ring (RA)
4 shaft retainer
shaft retainer
retaing ring (RA) arm washer
arm
washer
shaft retainer
Fig. 1
5 shaft roller assy
2 arm (roller)
1 tension spring (RA)
2-9. FLOATING BLOCK ASSY
6 floating block assy
7 compression spring (FL)
1 tension spring (KF1)
8 compression spring (FL)
4 Fit lever (D) in the
direction of the arrow.
5 Turn loading ring in the
direction of the arrow.
2 damper (T)
3 damper (T)
11
CDX-CA400/CA530X/CA580X
2-10. OPTICAL PICK-UP BLOCK
1 P 2x3
4 P 2x3
5 spring (feed), plate
2 sled motor assy
6 shaft (feed) assy
12
3 optical pick-up block
CDX-CA400/CA530X/CA580X
SECTION 3
DIAGRAMS
3-1. IC PIN DESCRIPTION
• IC801 µPD780076GK-520-9ET (SYSTEM CONTROLLER)
Pin No.
Pin Name
I/O
Pin Description
1
PH1
I
PH1 detection input (Not used in this set.)
2
3
D SW
IN SW/PH2
I
I
Down switch detection input
Disc in switch detection input
4
5
LM LD
LM EJ
O
O
Loading motor drive output (Loading)
Loading motor drive output (Eject)
6
7
ATT
A ATT
O
O
Line out mute control output
Power amplifier mute control output
8
9
PLL DI
VSSO
I
—
PLL IC data input
Ground pin
10
11
VDDO
PLL CLK
—
O
Power supply pin (+5 V)
PLL IC clock output
12
13
PLL DO
PLL CE
O
O
PLL IC data output
PLL IC chip enable output
14
15
BEEP
L V CE
O
O
BEEP output of key beep, caution alarm
Electric volume, LCD chip enable output
16
17
L V DO
L V CLK
O
O
Electric volume, LCD data output
Electric volume, LCD clock output
18
19
BUS SI
BUS SO
I
O
BUS interface serial input
BUS interface serial output
20
21
BUS CLK
BUS CK GEN
I
O
BUS interface serial clock input
BUS interface serial clock output
22
23
24
AM ON
FM ON
VDD1
O
O
—
Tuner AM power supply control output
Tuner FM power supply control output
Power supply pin (+5 V)
25
26
AVSS
ST IND
—
I
Ground pin
FM stereo detection input
27
28
PH3
S METER
I
I
PH3 detection input (Not used in this set.)
S meter signal input
29
30
KEY0
KEY1
I
I
A/D key input 0
A/D key input 1
31
32
ROTARY (AD)
DST SEL
I
I
Not used in this set.
Destination select input (Connect to ground in this set.)
33
34
TEST
AVREF
I
—
Force test mode input
A/D converter power supply pin (+5 V)
35
36
LCD INH
RESET
O
I
INHIBIT control output of LCD
Reset input (“L”: reset detection)
37
38
XT2
XT1
O
I
Sub clock output (32.768 kHz)
Sub clock input (32.768 kHz)
39
40
IC
X2
—
O
Connect to ground in this set.
Master clock output (8.38 MHz)
41
42
X1
VSS1
I
—
Master clock input (8.38 MHz)
Ground pin
43
44
KEY ACK
SIRCS
I
I
Key acknowledge detection input
Wireless remote control signal input
45
46
SELF SW
BU IN
I
I
Self switch detection input
Backup power supply detection input
47
48
NOSE
ILL ON
I
O
Front panel attachment detection input
Illumination power supply control output
49
50
A REMO
CDM ON
O
O
External amplifier remote control output
CD mechanism deck power supply control output
51
XCD ON
O
CD DSP IC 16 MHz X’tal on/off control output
13
CDX-CA400/CA530X/CA580X
Pin No.
52
Pin Name
SHIFT
I/O
—
53
54
BUS ON
SB RST
O
O
Enable output of bus IC
Reset output of bus IC
55
56
PW ON
X SO
O
O
System power supply control output
CD DSP IC serial data output
57
58
X SI
X SCK
I
O
CD DSP IC serial data input
CD DSP IC serial clock output
59
60
RFOK
CD RST
I
O
CD servo IC RFOK signal input
CD DSP IC reset control output
61
ACC IN
I
62
X AO
O
Accessory power supply detection input
CD servo IC command/parameter discrimination signal output
63
STB
O
“L”: Command, “H”: Parameter
CD servo IC data strobe signal output
64
L SW
I
CD sled limit switch detection input
14
Pin Description
Not used in this set.
CDX-CA400/CA530X/CA580X
3-2. BLOCK DIAGRAM — CD SECTION —
RF AMP,DIGITAL SERVO
DIGITAL SIGNAL PROCESSOR
IC1
OPTICAL PICK-UP
KSS-720A
A
84
C
85
(Page 16)
TUNER
SECTION
B
D
RF
EQ
A
B
82
DSUB CODE
PROCESS
C
I-V
CONV.
D
LOUT
16
ROUT
12
D/A
CONV
EFM
DEMOD
83
FORCUS
ERROR
I/F
E
E
87
F
86
PD
97
PD
SERVO
CTL
XTALEN
57 X_SI
58 X_SCK
63 STB
62 X A0
60 CD_RST
2
59 RFOK
9
X EN
B
62 63 64 65
FOCUS/TRACKING COIL DRIVE,
SLED/SPINDLE/LOADING MOTOR DRIVE
IC2
FCSFOCUS
COIL
FCS+
TRK+
TRACKING
COIL
TRK-
15
16
17
18
FOCUS
COIL
DRIVE
TRACKING
COIL
DRIVE
26
23
23
24
X1
16.9344MHz
FD
2 D_SW
SW1
(DOWN)
45 SELF_SW
SW2
(SELF)
TD
3 IN_SW
SW3
(DISC IN)
M902
(SLED)
M
SLSL+
M901
(SPINDLE)
M
M903
(LOADING)
M
SP+
SP-
LD-
13
14
11
12
9
LD+ 10
SLED
MOTOR
DRIVE
5
SPINDLE
MOTOR
DRIVE
6
LOADING
MOTOR
DRIVE
TUNER
SECTION
(Page 16)
MD
SD
TD
FD
LD
SYSTEM CONTROL
IC801(1/3)
56 X_SO
A5V
98
A
PACK
52
TSTB
56
TSCK
55
TSI
54
SI
8
SO
7
SCK
6
STB
5
AO
4
RST
3
RFOK
APC
OSC
LD
DRIVE
Q1
LD
F
TRACKING
ERROR
CDL
R-CH
64 L_SW
SW4
(LIMIT)
SD
IC902
RESET 36
1
MD
1
RESET
2
U_COM+5V
S901
(RESET)
LOAD
4 LM _LD
EJECT
2
5 LM_ EJ
A_5V
AU_5V
CD MECHANISM
ON SWITCH
Q905,906
CD+5V
REG
Q910,D910
D909
CD ON
SWITCH
Q921
D_5V
CD DRIVE
+6V REG
Q907,D908
DR_6V
15
50 CDM ON
BATT
15
51 XCD_ON
• Signal path
:CD
• R-ch is omitted due to
same as L-ch.
CDX-CA400/CA530X/CA580X
3-3. BLOCK DIAGRAM — TUNER SECTION —
PJ401
-3
L
BUS AUDIO IN
-4
R
R-CH
-1
L
AUDIO OUT REAR
-2
R
R-CH
POWER AMP
IC101
ELECTRONIC VOLUME
IC401
A
TUNER UNIT
TU601
CNJ601
(ANTENNA)
R-CH
CD
(Page 15) SECTION
L-CH 16
R-CH 17
1 AM_ANT DET_OUT 24
CDL
15 BUS L
23 BUS R
FL OUT 5
12
RL OUT 4
11
9
7
18 L1
R-CH
17 L2
21 R2
LCD CE
LCD DO
LCD CLK
C
2 CE
1 DI
36 CL
R-CH
LINE MUTE
Q102
AM_DX/LCL 3
FM_DX/LCL 4
8 LCL
FM/AM_OSC 11
15 FM_VCO
16 AM_VCO
18 FM_CP
19 VT
20 AM_CP
2
10
13
11
13
• FM/AM_VCC
25
TU+8V
FM POWER
CONTROL
Q605,606
AM POWER
CONTROL
Q603,604
OSC
SEEK
IFC
MONO
17 LV CLK
16 LV DO
15 LV CE
6
4
5
3
8
12
11
13
PLL_DI
PLL_DO
PLL_CLK
PLL_CE
3 RR+
11 RR–
LINE MUTE
CONTROL
Q401,402
ATT
BEEP
PW ON
A_ATT
6
14
55
7
ACC
CHECK
Q902
15 TEST
TEST 33
AMP/ANT
REMOTE CONTROL
Q911,917
BATT
COM+8V REG
Q918,919,929,D923
COM+8V
32 DST_SEL
BUS SI
BUS SO
BUS CLK
BUS CK GEN
18
19
20
21
BUS ON
SB RST
BU IN
FM_ON
53
54
TU+8V
BATT
F901
10A
18
16 +B (BATT)
BUS INTERFACE
IC802
46
23
CNJ801
BUS
CONTROL IN
8
BUS ON OUT 1
8 DATA OUT
9 DATA IN DATA IN/OUT 6
11 CLK IN
CD
SECTION
(Page 15)
6
5
4
BATT
DET
Q904,D907
3
2
1
7
12 BUS ON IN
13 RST OUT
BATT
TUNER +8V
REG
Q913,D913
19
U_COM+5 V REG
Q920,D930,D999
U_COM+5V
CLK OUT 4
TUNER ON
CONTROL
Q909,912
GND
17
AM_ON 22
D932
5 AMP REM
8
XI 24
9 AM_VCC
B
7 ACC
6 ANT REM
28 S_METER
26 SD_IND
X EN
R-CH
A REMO 49
XO 1
S_METER 21
SD/ST_IND 22
D931
4 FR+
12 FR–
4 STBY
22 MUTE
ACC IN 61
D_OUT
D_IN
CK
CE
X601
10.25MHz
12 FM_VCC
LINE MUTE
Q101
R-CH
PLL
IC601
OSC-IN 19
IF_COUNT 20
2 RL+
10 RL–
16 AUX-IN
FR OUT 33
RR OUT 34
SYSTEM CONTROL
IC801 (2/3)
FM_VT 6
AM_VT 14
1 FL+
9 FL–
14 AU-L
2 FM_ANT
DISPLAY
SECTION
(Page 17)
CNP901
5
3
BATT
:FM
RST OUT 2
10 BATT CHECK
• Signal path
BATT
BATT 3
D854
:AM
:CD
BATT
• R-ch is omitted due to
same as L-ch.
16
16
CDX-CA400/CA530X/CA580X
3-4. BLOCK DIAGRAM — DISPLAY SECTION —
TUNER
SECTION
(Page 16)
C
3-5. CIRCUIT BOARDS LOCATION
SERVO board
LCD DO
LCD CLK
LCD CE
IN SELF SW board
SYSTEM CONTROL
IC801 (3/3)
KEY 0
KEY MATRIX
S501-519
KEY 1
SPEAKER board
LCD DRIVE
IC551
29 KEY 0
62 DATA
CLK
61 CLK
CE
60 CE
30 KEY 1
1
|
23
SEG1
|
•
SEG52 25
|
53
57 INH
LCD INH 35
LCD
LCD501
COM1 64
•
•
COM2 63
43 KEY ACK
REMOTE CONTROL
RECEIVER
IC552
SIRCS 44
1 OUT
ILL B+
ILL ON 48
X802
32.768kHz
38 XT1
X2 40
X1 41
X801
8.38MHz
3 VCC
DISPLAY board
MAIN board
SL SW board
ILL POWER
CONTROL
Q914
BATT
37 XT2
tuner unit
(TU601)
D561-587
KEY
(ILLUMINATION
)
ILL B+
SWITCH
Q915
• Waveforms
— Servo Board —
BACK
( LCDLIGHT
)
PL551,552
— Main Board —
(MODE: CD PLAY)
1
1
2Vp-p
5Vp-p
32.768kHz
16.9344MHz
wd
IC1
(XTAL)
IC801
2
ej
(XT2)
2
3Vp-p
5Vp-p
3.2msec
IC1
ts
8.38MHz
IC801
(PACK)
3
1.2Vp-p
IC1
uj
(RFO)
4
0V
Approx. 100mVp-p
IC1
oa
(FEO)
5
0V
Approx. 100mVp-p
IC1
17
17
od
(TEO)
r;
(X2)
CDX-CA400/CA530X/CA580X
3-6. PRINTED WIRING BOARDS — CD MECHANISM SECTION — • Refer to page 17 for Circuit Boards Location.
12
11
10
9
8
7
6
5
4
3
2
1
A
THIS NOTE IS COMMON FOR PRINTED WIRING
BOARDS AND SCHEMATIC DIAGRAMS.
(In addition to this, the necessary note is
printed in each block.)
for schematic diagram:
• All capacitors are in µF unless otherwise noted. pF: µµF
50 WV or less are not indicated except for electrolytics
and tantalums.
• All resistors are in Ω and 1/4 W or less unless otherwise
specified.
•
%
: indicates tolerance.
f
•
: internal component.
• C : panel designation.
Note:
Note:
The components identi- Les composants identifiés par
fied by mark 0 or dotted une marque 0 sont critiques
line with mark 0 are criti- pour la sécurité.
Ne les remplacer que par une
cal for safety.
Replace only with part piéce portant le numéro
spécifié.
number specified.
B
CN2
C
• A : B+ Line.
• Power voltage is dc 14.4V and fed with regulated dc power
supply from ACC and BATT cords.
• Voltages are taken with a VOM (Input impedance 10 MΩ).
Voltage variations may be noted due to normal production tolerances.
• Waveforms are taken with a oscilloscope.
Voltage variations may be noted due to normal production tolerances.
• Circled numbers refer to waveforms.
• Signal path.
F : FM
f : AM
J : CD
D
for printed wiring boards:
• X : parts extracted from the component side.
• Y : parts extracted from the conductor side.
•
x
: parts mounted on the conductor side.
a
•
: Through hole.
•
: Pattern from the side which enables seeing.
(The other layer’s patterns are not indicated.)
F
Caution:
Pattern face side:
(Side B)
Parts face side:
(Side A)
E
G
Parts on the pattern face side seen from the
pattern face are indicated.
Parts on the parts face side seen from the
parts face are indicated.
H
SW1
I
J
18
18
CDX-CA400/CA530X/CA580X
1
2
3
4
5
6
7
8
9
10
11
A
13
14
• Semiconductor
Location
TP63
C1
TP64
R3
R26
TP52
SW3
TP12
C6
R5
C9 C10
C11
C8
TP59
FB6
TP83
TP11
TP8
TP51
D
TP79
TP60
FB7 TP50
C43
C3
TP9
R22
TP81
Q1
TP80
TP47
R21
TP71
TP56
TP70
C18
C14
TP58
TP23
C41
R19
TP61
C27
TP88
C34
TP74
C29
TP68
TP75
C36
TP49
X1
TP34
TP36
TP57
F
C38
FB2
TP39
R20
C44
FB4
TP85
C35
TP37
TP38
TP55
TP41
TP18
TP30
G
R24
TP73
SW4
TP44
TP43
TP92
C26
FB3
TP45
TP35 TP46
TP42
TP69
SW2
TP25
IC1
C45
TP76
TP40
E
R8
C24
TP22
TP24
C25
C40
(Page 21)
C20
C19
C23
R9
C17
FB1
R17
TP72
C16
R18
TP10
TP89
C15
CN1
C-6
TP84
R29
TP48
C
Q1
TP82
C4
TP66
Location
E-7
H-7
C5
R30
C13
TP62
Ref. No.
IC1
IC2
TP78
TP77
TP7
B
TP21
TP32
R25
TP6
R7
R6
R15
TP91
TP86
C22
H
TP90
TP87
C37
TP26
TP29
TP19
TP4
C30
TP20
CN3
TP5
IC2
C21
TP54
R14
R10 R12
TP53
I
12
TP28
TP3
TP17
TP2
TP27
TP16
TP1
J
19
19
CDX-CA400/CA530X/CA580X
• Refer to page 17 for Waveforms.
3-7. SCHEMATIC DIAGRAM — CD MECHANISM SECTION — • Refer to page 26 for IC Block Diagrams.
CN2
TP8
C23
C20
C19
R26
C1
C5
TP79
TP80
C43
R8
C18
C4
TP89
FB2
FB4
C24
R9
TP88
R3
R29
R30
TP77
TP78
TP9
TP22
TP23
TP24
TP25
Q1
C35
C6
C3
C14
TP81
TP82
TP83
TP84
TP45
TP44
TP43
TP42
TP41
TP10
C13
C11
R5
TP40
TP39
TP38
TP37
SW4
TP7
C15
IC1
TP46
C10
TP36
C38
TP12 C9
TP11
CN13
CN3
C8
TP85
TP35
TP34
M902
C16
C36
M901
IC B/D
C44
C25
TP92
C29
CN1
C17
FB1
C40
R18
C34
FB3
C45
TP1
TP5
C26
C27
C41
X1
SW1
R19
R20
TP6
R17
TP4
TP2
SW2
SW3
R7
TP3
TP30
TP21
TP18
TP32
TP66
R15
R24
R25
TP51
R12
R22
FB7
TP50
TP64
TP49
R14
C22
R10
IC2
R21
C21
TP90
C30
R6
TP91
TP87
IC B/D
M903
TP86
Note:
• Voltage is dc with respect to
ground under no-signal conditions.
no mark : CD PLAY
20
20
FB6
TP48
TP63
TP47
TP62
C37
TP27
TP29
TP26
TP28
TP17
TP20
TP16
TP19
TP61
TP76
TP60
TP75
TP59
TP74
TP58
TP73
TP57
TP72
TP56
TP71
TP55
TP70
TP54
TP69
TP53
TP68
TP52
(Page 22)
CDX-CA400/CA530X/CA580X
3-8. PRINTED WIRING BOARD — MAIN SECTION — • Refer to page 17 for Circuit Boards Location.
2
1
3
4
5
6
7
8
9
10
11
12
13
14
PJ401
A
CNJ601
CNJ801
CNP901
C102
D919
JW86
JW84
R853
R901 D853
JW96
JW94
JW95
JW93
JW91
JW92
R908
JW97
Q904
JW76
Q402
R909
Q902
R905
Q929
JR929
L702
Q906
C909
Q915
JW115
R819
S901
(Page 24)
21
21
JW117
R929
JW119
R928
R926
R925
C916
JR903
CNP801
JW118
JW114
JW116
JW113
JW110
R824
JR904
C802
C801
R920
C915
R924
R919
JW112
R923
C914
R930
R918
Q914
JW111
C846
JW109
02
X8
JW124
C803
JW5
R922
C810
JW120
R813
JW87
D901
D915
D917
D916
Q401
R705
R814
JW7
JW122
JW121
JW9
C913
D999
D930
X801
JW10
R840
JW85
D921
D918
R810
C809
JW2
JW1
JW3
Q911
IC801
R846
R844
(Page 19)
D913
R931
Q920
R845
JW11
Q913
R917
IC902
R807
R615 JW13
JR603
R712
JW14
D802
D807
D809
D808
D806
D803
D804
D805
R835
JW4
R912
JW106
R849
R848
R812
JW8
R933
D909
R932
Q905
JW12
D931
I
Q921
JW108
R847
TH901
JW100
JW104
JW42
JW41
D908
Q917
Q912
JW151
JW150
R911
R913
JW107
R811
Q606
C841
C842
R618
JR605
JW24
R806
L604
R934
Q919
R710
R711
CNP701
JW146
JW102
JW105
JW43
C623
R617
R708
JW44
R851
D923
R709
R610
C621
JW22
C625
Q909
JW152
JW147
C905
JW103
JW45
C626
X601
R605
C608
JW23
C624
C622
C618
C617
R619
R907
JW153
JW148
JW101
R706
R707
JW48
JW46
IC601
C704
JW149
D907
C919
L701
JW47
Q604
C619
C652
R628
Q605
H
R604
R608
R616
JW15
C848
R609
Q603
C620
C703
C707
JR110
C633
C614
R607
JW21
JW19
R622
JW20
JW16
G
C612
C613
C615
C650
JW17
R620
C611 R606 R611
C610
C651
R716
R704
C118
C631
C606
JW99
Q910
JW50
R612
D854
C904
C702
JW54
R808
C609
R601
D852
JW98
C804
JR606
R613 L603
JW90
L703
R714
JW51
JW49
JR607
D903
Q918
JW29
L901
D851
D910
JW53
JW52
C119
R603
C217
C220
JW30
C701
C706
C219
JW81
JW88
JW89
C907
C215
D932
JW27
C117
C627
JW18
C120
C432
R404
R815
JW32
C216
JW31
JW28
R809
R215
C116
R444
C847
JW123
C114
R614
C214
C218
F
JW55
C213
C113
JW26
R602
C605
JW59
R213
C115
D604
C604
JW56
R401
C211
C208
IC401
JW83
R854
JW77
R410
D444
C110
R906
D933
IC802
JW57
C210
TH851
JW82
C931
JW75
JW58
JW35
C111
E
D922
R407
C108
C603
JW73
D401
C435
R115
1
C90
JW74
R408
R821
JW33
JW60
JW34
R113
C669
JW61
C401
C204
C104
C103
TU601
D
JW62
C203
CP601
C851
JW80
JW65
JW63
Q201
JW39
JW79
JW66
JW64
R207
L669
JW78
JW67
R209
Q102
R109 Q101
JW38
JW37
JW36
R210 Q202
JW40
R110
C
R108
JW68
C202
R205
R122
Q907
C201
R106
R927
R105
R107
R852
JW69
C426
R208
R222 R221
R121
C869
R206
D920
C221
IC101
C407
C101
J
JW71
JW70
B
JW72
D402
C121
C105
C671
C205
C672
• Semiconductor Location
Ref. No. Location
Ref. No.
IC101
D401
D-4
IC401
D402
D-7
IC601
D444
E-6
IC801
D604
E-2
D802
I-4
IC802
D803
I-3
IC902
D804
I-3
D805
I-3
Q101
D806
I-3
Q102
D807
I-3
Q201
D808
I-3
Q202
D809
I-3
Q401
D851
D-9
Q402
D852
D-9
Q603
D853
D-9
Q604
D854
E-10
Q605
D901
D-9
Q606
D903
D-8
Q902
D907
E-10
Q904
D908
E-10
Q905
D909
G-10
Q906
D910
E-7
Q907
D913
G-10
Q909
D915
D-6
Q910
D916
D-6
Q911
D917
D-6
Q912
D918
D-6
Q913
D919
B-7
Q914
D920
B-7
Q915
D921
C-6
Q917
D922
C-5
Q918
D923
F-8
Q919
D930
H-9
Q920
D931
I-4
Q921
D932
H-4
Q929
D933
D-8
D999
G-10
Location
B-6
E-4
G-3
H-7
D-7
I-9
C-3
C-3
C-4
C-4
D-6
E-6
H-2
H-4
H-2
H-3
E-9
E-10
G-8
H-8
C-10
F-9
E-8
H-8
G-9
G-10
H-8
H-9
F-10
F-8
G-8
H-9
F-9
F-8
15
CDX-CA400/CA530X/CA580X
3-9. SCHEMATIC DIAGRAM — MAIN SECTION (1/2) — • Refer to page 17 for Waveforms.
IC802
R853
R852
R851
Q907
R933
Q910
D854
Q919
TH901
Q906
Q918
Q905
R912
D909
Q917
Q904
R905
R932
Q921
JR929
R934
D910
D908
R913
R911
D907
Q929
Q911
C905
C919
D923
C907
TH851
R714
C706
R716
C707
R821
CNJ801
X802
C869
D853
R408
C801 C802
R407
C803
C804
X801
D930
Q920
R854
D851
C851
D852
(Page 23)
C909
R931
R930
R819
D999
L703
R815
R814
R813
Q909
C847
Q912
R840
R917
C810
IC801
Q913
(Page
20)
C701
C913
D913
R844
CNP701
R845
R846
R812
C914
L701
C702
R918
C846
L702
C703
Q914
Q915
C704
IC902
R704
R849
R848
R847
R712
R711
R710
R928
R929
R924
R925
JR903
R709
R708
R810
R811
R809
R705
R706
R926
R927
R707
C916
R920
R919
C915
S901
D931
R922
R808
R807
R806
R923
CNP801
D932
R824
JR904
R835
D802
D809
D808
D806
D807
D803
D804
D805
(Page 25)
Note:
• Voltage is dc with respect
to ground under no-signal
(detuned) condition.
no mark : FM
(
) : AM
<
> : CD PLAY
C809
22
22
CDX-CA400/CA530X/CA580X
3-10. SCHEMATIC DIAGRAM — MAIN SECTION (2/2) — • Refer to page 26 for IC Block Diagrams.
L901
D901
R105
C901
CNP901
R206
D933
R109 C103
Q101
C205
C105
R107
C401
C931
C671
F901
Q102
IC101
R108
D922
C201
R401
PJ401
C121
C221
R221
D444
R209
R205
R444
D921
D920
R122
R222
C104
R110
R106
R121
Q201
R207
Q202
R208
C203
C202
D919
D917
R210
CNJ601
C204
R410
C102
Q401
D402
D918
D915
C101
C432
CP601
D916
C672
TU601
R908
Q902
R909
R907
R901
C904
R906
Q402
C407
C426
D903
L669
C669
L601
R404
C603
IC B/D
D401
C604
IC401
R601
JR110
Note:
• Voltage is dc with respect to ground under
no-signal (detuned) condition.
no mark : FM
(
) : AM
<
> : CD
IC B/D
R612
C619
R606
R609
C435
R613
R611
C208
C108
R113 C110
C111
C113
R215
C213
C214
R115
C114
C115
C610
L603
C612
C613
C210 R213
C211
R619
C631
JR605
C215
C216
R607
R608
C117
C618
(Page22)
C220
R602
R603
C606
C615
C614
C633
C217
C116
C605
C609
C611
IC601
C617
C621 C620
JR606
C120
R620
R610 C626
C218
C622
C119
C650
C219
C625
C624
L604
C623
X601
R622
C651
R605
R604
C848
C118
JR607
C652
R628
Q605
C608
R618
Q603
R617
R614
JR603
R616
R615
Q606
C842
Q604
C841
23
23
C627
D604
CDX-CA400/CA530X/CA580X
3-11. PRINTED WIRING BOARD — DISPLAY SECTION — • Refer to page 17 for Circuit Boards Location.
2
1
3
4
5
6
7
8
9
10
11
12
13
14
A
D574
D576
D577
D578
IC552
R555
D575
R574
D570
D571
R573
R572
D555
D573
R577
D564
R578
R565
R566
R567
R568
B
R571
R554
D567
D583
D582
D568
D565
D566
D563
D580
D586
D587
D
D562
R575
R576
D561
D584
R580
R570
R579
D569
D585
D579
R569
C
R564
R563
D572
D581
E
S504
S515
JR507
R517
S517
R518
S518
S519
R519
S509
S508
S507
R505
R504
R506
R507
D554
R516
R509
IC
55
1
S510
R508
C552
D553
CNP552
R503
R560
JR506
R510
CNP551
H
R515
S503
PL551
D551
JR508
R501
R511
S506
D556
JR505
R551
S512
JR504
S514
R552
PL552
G
R502
LCD501
C553
R513
S502
S505
S513
R512
R514
S511
R559
R562
JR503
C551
F
R561
S501
S516
I
• Semiconductor Location
Ref. No.
D551
D553
D554
D555
D556
D561
D562
D563
D564
(Page 21)
24
24
Location
G-5
H-5
H-6
A-13
G-5
C-1
D-1
C-3
B-2
Ref. No.
D565
D566
D567
D568
D569
D570
D571
D572
D573
Location
C-2
C-2
A-1
B-1
C-1
A-5
A-4
B-3
A-8
Ref. No.
D574
D575
D576
D577
D578
D579
D580
D581
D582
Location
A-7
A-6
A-9
A-10
A-11
B-12
C-12
D-13
B-13
Ref. No.
D583
D584
D585
D586
D587
Location
B-14
C-14
C-13
C-13
C-14
IC551
IC552
G-8
A-13
CDX-CA400/CA530X/CA580X
3-12. SCHEMATIC DIAGRAM — DISPLAY SECTION —
D551
R552
C552
R551
D556
C551
C553
R554
CNP551
CNP552
D573
D576
D579
D582
R579
R580
D570
R566
R565
R563
R564
JR504
R555
D567
PL551
D555
D577
D580
D585
R568
R577
D574
R578
D571
R567
R561
JR508
D564
R562
R559
R560
D561
JR507
IC552
IC551
JR505
D563
D566
D569
D575
D578
D583
D586
D584
D587
R576
D568
R575
D565
R570
D562
R569
PL552
D554
D553
R574
R573
D581
R572
D572
R571
(Page 22)
JR506
S501
S502
S503
JR503
R501
R502
S511
S512
R511
R512
R503
S504
R504
S513
S505
LCD501
R513
R505
S514
S506
S507
S508
S509
S510
R506
R507
R508
R509
R510
S515
S516
S517
S518
S519
R514
R515
R516
R517
R518
R519
Note:
• Voltage is dc with respect to ground under no-signal
(detuned) condition.
no mark : FM
25
25
CDX-CA400/CA530X/CA580X
• IC BLOCK DIAGRAMS
IC2 BA5810FP-E2
MD
SD
TD
FD
AGND
ATEST
TEST1
TEST0
DGND
TSTB
TSCK
TSI
TSO
PACK
DVDD
66
65
64
63
62
61
60
59
58
57
56
55
54
53
52
51
COMPARATOR
CD-TEXT DECODER
D/A
FD/TD/SD/MD
CONTROLLER
PS
4
IN1
5
IN2
6
PREVCC
(PRE.LOADING)
POWVCC12
(CH1.CH2)
42 RFCK
TIMING GENERATOR
ROM
DECODER
SVROM
40 DVDD
EFM
TEO 93
FEO
TEC 95
DE-EMPHASIS CIRCUIT
TRACKING
REGISTER
FOCUS
REGISTER
TEO
AGND 96
OCTUPLED
OVERSAMPLING DIGITAL FILTER
COMPARATOR
PD 97
NOISE SHAVER
–
VO2– 11
36 TX
VO2+ 12
–
VO1– 13
–
LEVEL
SHIFT
10k
10k
10k
–
VO1+ 14
–
LEVEL
SHIFT
LEVEL
SHIFT
–
10k
10k
10k
10k
18 VO3–
17 VO3+
10k
10k
10k
33 LRCKIN
32 SCKO
LEVEL
SHIFT
–
10k
34 LRCK
10k
10k
10k
+
MIRR
TE2 94
RFENV
MIRENV
37 DGND
35 HOLD/WDCK
OUTPUT PROCESSOR
A3T
21 MUTE
19 GND
+
A/D CONVERTER
FOK
TE- 92
D/A
INTERFACE
CIRCUIT
CH1-4
MUTE
VOL+ 10
+
DIGITAL
AUDIO
INTERFACE
DEFECT
COMPARATOR
DEFECT
+
POWVCC34
(CH3,CH4)
+
FE- 90
9
38 C16M
SWITCH
FEO 91
VOL–
+
20 POWVCC
39 TSOI
CLV
PROCESSOR
REFOUT 89
8
22 OPOUT3
41 LOCK
F 86
AVDD 88
POWVCC
+
10k
+
RF
AMP BLOCK
SVCRAM
+
–
MULTIPLIER
B 84
E 87
7
43 MIRR/WFCK
SVDRAM
TEOFS
D 85
PREVCC
44 PLCK
24 OPIN3+
23 OPIN3–
–
16k
C 83
DIGITAL PLL
EFM DEMODULATOR
25 OPOUT4
–
ADDER
FEOFS
POWER
SAVE
47 C1D2
45 DGND
A 82
X3
48 C2D1
46 C1D1
AGND 81
3
27 OPIN4+
26 OPIN4–
–
+
AUTO GAIN
CONTROLLER
RF- 80
SUB-CODE PROCESSOR
16K
SRAM
MEMORY
PROCESSOR
LDCONT
LOADING PRE
FWD REV
+
EQ1 79
2
16 VO4–
15 VO4+
–
EFM
49 C2D2
REV
28 BIAS
–
EQ2 78
50 C2D3
ERROR
CORRECTION
PROCESSOR
EFM
RFO 77
1
+
AGCI 76
MICROCOMPUTER INTERFACE
FWD
+
7F DAC0
67
+
7C DAC1
68
16k
7D DAC2
69
16k
7E DAC3
70
7.5k
AVDD
71
7.5k
EFM
72
7.5k
ASY
73
–
C3T
74
16k
RFI
75
7.5k
AGCO
IC1 µPD63711GC-8EU
10k
31 SCKIN
30 DOUT
29 DIN
NOISE SHAVER
LD 98
28 FLAG
OUTPUT BUFFER OUTPUT BUFFER
27 EMPH
PN 99
AVDD 100
MICROCOMPUTER INTERFACE
SCF
26 DVDD
OSC
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
RFOK
RST
A0
STB
SCK
SO
SI
XTALEN
DVDD
DAVDD
ROUT
DAGND
REGC
DAGND
LOUT
DAVDD
R+
R–
L–
L+
XVDD
XTAL
XTAL
XGND
XO
1
OSC
2
OSCILLATOR
BUFFER
24 XI
23 A-GND
22 REG
REGULATOR
ON/OFF
REFERENCE
DIVIDER
SEEK/RECP
21 VCC
VCC
20 AM_CP
–
+
5
3
4
5
6
SR
7
SERIAL
INTERFACE
SEEK/RECP
18 FM_CP
17 D-GND
18BIT
12BIT
PROGRAMMABLE
COUNTER
18BIT
19 VT
PRESCALLER
4BIT SWALLOW
COUNTER
+
CE
D_IN
CK
D_OUT
PHASE
COMPARATOR
+
40BIT SHIFT
REGISTER
+
4
REF
3
SIG
2
–
1
DGND
IC601 TB2118F-EL-S
LCL
8
I/O-2
9
SEEK 10
MONO 11
VDD2 12
26
26
AMP
AMP
I/O
PORT
VDD2
15 FM_VCO
VDD
22BIT
OUTPUT
PORT
20BIT
IF COUNTER
AMP
16 AM_VCO
14 VDD
13 IFC
CDX-CA400/CA530X/CA580X
IC401 LC75421M-TLM-E
36 CL
2
35 VDD
VSS
3
LROUT
4
34 RROUT
LFOUT
5
33 RFOUT
–
+
–
+
–
1
–
DI
CE
+
+
CCB
INTERFACE
7
32 RFIN
31 ROUT
+
–
–
6
+
LFIN
LOUT
8
30 RSB
LBASS2
9
29 RBASS2
LOGIC
CIRCUIT
CONTROL
CIRCUIT
CONTROL
CIRCUIT
+
+
–
–
LSB
28 RBASS1
+
+
LVREF
–
–
LBASS1 10
RVREF
27 RTRE
LTRE 11
–
–
LIN 12
26 RIN
+
+
LSELO 13
25 RSELO
L5
14
24 R5
L4
15
23 R4
L3
16
22 R3
L2
17
18
–
+
+
L1
21 R2
–
20 R1
19 VREF
27
CDX-CA400/CA530X/CA580X
SECTION 4
EXPLODED VIEWS
NOTE:
• The mechanical parts with no reference
number in the exploded views are not supplied.
• Items marked “*” are not stocked since
they are seldom required for routine service.
Some delay should be anticipated
when ordering these items.
• -XX and -X mean standardized parts, so
they may have some difference from the
original one.
• Color Indication of Appearance Parts
Example :
KNOB, BALANCE (WHITE) ... (RED)
R
R
Parts Color Cabinet’s Color
• Accessories are given in the last of this
parts list.
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
Les composants identifiés par une
marque 0 sont critiques pour
la sécurité.
Ne les remplacer que par une piéce
portant le numéro spécifié.
4-1. CHASSIS SECTION
5
MG-393XA-121//K
3
#1
4
#2
#2
6
#2
#3
10
11
2
#2
#2
#2
9
7
8
TU601
F901
12
6
13
#1
#1
#1
15
1
#1
14
Ref. No.
Part No.
Description
* 1
2
3
* 4
* 5
3-224-612-01
3-224-309-21
1-776-206-21
3-024-285-01
3-041-173-11
CHASSIS (CD)
COVER
CORD (WITH CONNECTOR) (POWER)
CUSHION (RUBBER)
BRACKET (CD)
6
7
8
* 9
10
3-922-535-11
A-3283-245-A
3-236-922-01
3-019-565-01
1-683-830-11
SCREW (+BTT)
MAIN BOARD, COMPLETE
HEAT SINK
BRACKET (IC)
SPEAKER BOARD
28
Remark
Ref. No.
Part No.
Description
11
* 12
13
14
15
3-041-261-11
3-048-259-01
X-3380-594-3
X-3381-269-1
3-231-472-01
BRACKET (TR)
SHEET (E)
LOCK ASSY (S)
PANEL (1) ASSY, SUB
SCREW (+B 2X4)
1-532-877-11
A-3220-835-A
7-685-792-09
7-685-793-09
7-685-795-09
FUSE (BLADE TYPE) (AUTO FUSE) 10A
TUNER UNIT (TUX-010)
SCREW +PTT 2.6X6 (S)
SCREW +PTT 2.6X8 (S)
SCREW +PTT 2.6X12 (S)
F901
TU601
#1
#2
#3
Remark
CDX-CA400/CA530X/CA580X
4-2. FRONT PANEL SECTION
69
70
#4
67
LCD501
71
#4
72
68
66
61
60
not supplied
(DISPLAY board)
65
64
62
55
63
54
53
59
58
52
57
56
Ref. No.
Part No.
Description
51
51
51
52
53
X-3381-640-1
X-3381-641-1
X-3381-642-1
3-236-909-01
3-236-912-01
PANEL (S) ASSY, FRONT (CA400)
PANEL (S) ASSY, FRONT (CA530X)
PANEL (S) ASSY, FRONT (CA580X)
BUTTON (OFF)
BUTTON (EJECT)
54
55
56
57
58
3-236-908-01
3-236-910-01
3-236-905-01
X-3381-356-1
3-236-904-01
BUTTON (MBP)
BUTTON (1-6)
BUTTON (D-BASS)
RING (SEEK) ASSY
BUTTON (SOURCE)
59
60
61
62
X-3381-355-1
3-236-911-01
3-229-774-01
3-236-907-01
RING (VOL) ASSY
BUTTON (RELEASE)
SPRING (RELEASE)
BUTTON (MODE)
51
Remark
Ref. No.
Part No.
Description
63
64
* 65
66
67
3-236-906-01
3-236-921-01
3-229-751-01
3-236-920-01
X-3381-357-1
BUTTON (SEL)
PLATE (LCD), GROUND
SHEET (LCD.UP)
SHEET (LCD), DIFFUSION
HOLDER (LCD) ASSY
68
69
70
70
70
3-236-902-01
X-3380-054-2
A-3337-073-A
A-3337-074-A
A-3337-075-A
PANEL, FRONT BACK
CASE ASSY (for FRONT PANEL)
PANEL COMPLETE ASSY, FRONT (CA400)
PANEL COMPLETE ASSY, FRONT (CA530X)
PANEL COMPLETE ASSY, FRONT (CA580X)
3-227-293-01
3-236-926-01
1-804-626-11
7-685-106-19
SHEET (LCD)
CUSHION (LCD)
DISPLAY PANEL, LIQUID CRYSTAL
SCREW +P 2X10 TYPE2 NON-SLIT
* 71
72
LCD501
#4
Remark
29
CDX-CA400/CA530X/CA580X
4-3. CD MECHANISM SECTION (1)
(MG-393XA-121//K)
102
#8
#8
104
103
107
109
101
116
115
114
106
114
105
111
105
C
117
113
C
110
#9
M903
112
#7
#7
108
Ref. No.
Part No.
Description
101
102
103
104
105
1-683-283-11
3-040-039-02
3-040-038-01
3-040-050-01
3-040-022-01
IN SELF SW BOARD
CHASSIS (T)
SPRING (LR), TENSION
LEVER (L)
RETAINER (ROLLER), SHAFT
106
107
108
109
110
3-040-044-01
3-040-067-01
A-3301-980-A
3-040-037-01
3-040-040-02
ROLLER (S)
LEVER (R)
SHAFT ROLLER ASSY
GUIDE (DISC)
ARM (ROLLER)
111
A-3283-233-A SERVO BOARD, COMPLETE
30
Remark
Ref. No.
#8
Part No.
Description
112
113
114
115
116
3-221-779-01
3-040-034-01
3-040-042-01
3-043-880-01
3-044-206-11
BRACKET (MOTOR)
SPRING (RA), TENSION
WASHER
RING (RA), RETAINING
SCREW, SPECIAL
117
M903
#7
#8
#9
1-683-284-11
A-3315-039-A
7-628-253-00
7-627-553-37
7-627-553-17
FLEXIBLE BOARD
MOTOR SUB ASSY, LO (LOADING)
SCREW, SPECIAL
SCREW, PRECISION +P 2X3 TYPE3
SCREW, PRECISION +P 2X2 TYPE3
Remark
CDX-CA400/CA530X/CA580X
4-4. CD MECHANISM SECTION (2)
(MG-393XA-121//K)
154
151
156
157
157
158
D
164
160
not supplied
162
153
155
163
161
D
159
152
152
152
Ref. No.
Part No.
Description
151
152
153
154
155
3-040-025-01
3-040-031-01
3-040-056-01
3-040-024-01
3-040-054-01
ARM, CHUCKING
DAMPER (T)
LEVER (D)
RETAINER (DISC)
WHEEL (LW), WORM
156
157
3-040-026-01 SPRING (CH), TENSION
3-040-032-01 SPRING (FL), COMPRESSION
Remark
Ref. No.
Part No.
Description
158
159
160
161
162
3-040-033-01
A-3307-422-A
3-040-059-01
3-040-057-01
3-040-058-01
SPRING (KF1), TENSION
CHASSIS (M) COMPLETE ASSY
SPRING (TR), TENSION
LEVER (LOCK)
GEAR (MDL)
163
164
3-040-052-01 WHEEL (U), WORM
3-040-051-02 LEVER (TR)
Remark
31
CDX-CA400/CA530X/CA580X
4-5. CD MECHANISM SECTION (3)
(MG-393XA-121//K)
201
M901
207
202
M902
203
208
#10
209
210
#8
204
205
206
#11
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
Ref. No.
Part No.
Description
201
202
203
204
205
X-3378-480-1
3-040-029-01
3-040-045-01
3-040-194-01
A-3301-983-A
CHASSIS (OP) ASSY (including M901)
SPRING (SL), TORSION
BASE (DRIVING)
GEAR (MIDWAY)
SHAFT (FEED) ASSY
206
207
3-040-030-01 SPRING (FEED), PLATE
1-823-641-11 CABLE, FLEXIBLE FLAT (6 CORE)
32
Remark
Les composants identifiés par une
marque 0 sont critiques pour
la sécurité.
Ne les remplacer que par une piéce
portant le numéro spécifié.
Ref. No.
Part No.
Description
208
209
0 210
M902
#8
1-683-282-11
3-909-607-01
8-820-103-11
A-3301-985-A
7-627-553-37
SL SW BOARD
SCREW
PICK-UP, OPTICAL KSS-720A/C-RP
MOTOR ASSY, SLED (SLED)
SCREW, PRECISION +P 2X3 TYPE3
#10
#11
7-627-850-28 SCREW, PRECISION +P 1.4X3
7-685-780-01 SCREW +PTT 2X3 (S)
Remark
CDX-CA400/CA530X/CA580X
SECTION 5
ELECTRICAL PARTS LIST
NOTE:
• Due to standardization, replacements in
the parts list may be different from the
parts specified in the diagrams or the
components used on the set.
• -XX and -X mean standardized parts, so
they may have some difference from the
original one.
• RESISTORS
All resistors are in ohms.
METAL:Metal-film resistor.
METAL OXIDE: Metal oxide-film resistor.
F:nonflammable
• Items marked “*” are not stocked since
they are seldom required for routine service.
Some delay should be anticipated
when ordering these items.
• SEMICONDUCTORS
In each case, u : µ, for example:
uA.. : µA.. uPA.. : µPA..
uPB.. : µPB.. uPC.. : µPC.. uPD.. : µPD..
• CAPACITORS
uF : µF
• COILS
uH : µH
DISPLAY
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
Les composants identifiés par une
marque 0 sont critiques pour
la sécurité.
Ne les remplacer que par une piéce
portant le numéro spécifié.
When indicating parts by reference
number, please include the board.
Ref. No.
Part No.
Description
Remark
DISPLAY BOARD
**************
3-227-293-01
3-229-751-01
3-236-920-01
3-236-921-01
X-3381-357-1
*
*
SHEET (LCD)
SHEET (LCD.UP)
SHEET (LCD), DIFFUSION
PLATE (LCD), GROUND
HOLDER (LCD) ASSY
< CAPACITOR >
C551
C552
C553
1-164-315-11 CERAMIC CHIP
1-164-156-11 CERAMIC CHIP
1-162-927-11 CERAMIC CHIP
470PF
0.1uF
100PF
5%
5%
50V
25V
50V
Ref. No.
Part No.
Description
D569
D570
D570
D571
D571
8-719-078-21
8-719-038-05
8-719-053-09
8-719-038-05
8-719-053-09
LED
LED
LED
LED
LED
D572
D572
D573
D573
8-719-053-08
8-719-053-09
8-719-038-05
8-719-053-09
LED
LED
LED
LED
D574
D574
< CONNECTOR >
* CNP551 1-779-131-11 PIN, CONNECTOR 2P
CNP552 1-794-312-21 PIN, CONNECTOR 12P
D575
D575
D576
D576
< DIODE >
D551
D553
D554
D555
D556
8-719-073-15
8-719-067-70
8-719-068-68
8-719-073-15
8-719-067-70
D561
8-719-053-09 LED SML-310VTT86 (SEEK2)
(CA530X/CA580X)
8-719-078-21 LED SML-310PTT86 (SEEK2) (CA400)
8-719-053-09 LED SML-310VTT86 (Z) (CA530X/CA580X)
8-719-038-05 LED CL-190FG-CD-T (Z) (CA400)
8-719-053-08 LED SML-310DTT86 (MBP) (CA530X/CA580X)
D561
D562
D562
D563
D563
D564
D564
D565
D565
D566
D566
D567
D567
D568
D568
D569
DIODE
DIODE
DIODE
DIODE
DIODE
SDZ5V1
SDZ6V2
SDZ6V2WA
SDZ5V1
SDZ6V2
8-719-053-09 LED SML-310VTT86 (MBP) (CA400)
8-719-053-09 LED SML-310VTT86 (SEEK5)
(CA530X/CA580X)
8-719-078-21 LED SML-310PTT86 (SEEK5) (CA400)
8-719-053-09 LED SML-310VTT86 (DSO) (CA530X/CA580X)
8-719-078-21 LED SML-310PTT86 (DSO) (CA400)
8-719-053-09 LED SML-310VTT86 (SEEK1)
(CA530X/CA580X)
8-719-078-21 LED SML-310PTT86 (SEEK1) (CA400)
8-719-038-05 LED CL-190FG-CD-T (OFF) (CA400)
8-719-053-09 LED SML-310VTT86 (OFF) (CA530X/CA580X)
8-719-053-09 LED SML-310VTT86 (SEEK4)
(CA530X/CA580X)
8-719-078-21 LED SML-310PTT86 (SEEK4) (CA400)
8-719-053-09 LED SML-310VTT86 (SEEK3)
(CA530X/CA580X)
D577
D577
D578
D578
D579
SML-310PTT86 (SEEK3) (CA400)
CL-190FG-CD-T (6) (CA400)
SML-310VTT86 (6) (CA530X/CA580X)
CL-190FG-CD-T (SENS) (CA400)
SML-310VTT86 (SENS)
(CA530X/CA580X)
SML-310DTT86 (BTM) (CA530X/CA580X)
SML-310VTT86 (BTM) (CA400)
CL-190FG-CD-T (3/REP) (CA400)
SML-310VTT86 (3/REP)
(CA530X/CA580X)
8-719-038-05 LED CL-190FG-CD-T (4/SHUF) (CA400)
8-719-053-09 LED SML-310VTT86 (4/SHUF)
(CA530X/CA580X)
8-719-038-05 LED CL-190FG-CD-T (5) (CA400)
8-719-053-09 LED SML-310VTT86 (5) (CA530X/CA580X)
8-719-038-05 LED CL-190FG-CD-T (2/DISC +) (CA400)
8-719-053-09 LED SML-310VTT86 (2/DISC +)
(CA530X/CA580X)
8-719-038-05 LED CL-190FG-CD-T (1/DISC –) (CA400)
8-719-053-09 LED SML-310VTT86 (1/DISC –)
(CA530X/CA580X)
8-719-038-05 LED CL-190FG-CD-T (ATT) (CA400)
8-719-053-09 LED SML-310VTT86 (ATT) (CA530X/CA580X)
8-719-053-08 LED SML-310DTT86 (DSPL)
(CA530X/CA580X)
D579
D580
D580
D581
D581
8-719-053-09
8-719-053-08
8-719-053-09
8-719-038-05
8-719-053-09
D582
8-719-053-09 LED SML-310VTT86 (VOL3)
D582
D583
D583
D584
D584
D585
D585
D586
D586
Remark
LED
LED
LED
LED
LED
SML-310VTT86 (DSPL) (CA400)
SML-310DTT86 (SEL) (CA530X/CA580X)
SML-310VTT86 (SEL) (CA400)
CL-190FG-CD-T (MODE) (CA400)
SML-310VTT86 (MODE)
(CA530X/CA580X)
(CA530X/CA580X)
8-719-078-21 LED SML-310PTT86 (VOL3) (CA400)
8-719-053-09 LED SML-310VTT86 (VOL4)
(CA530X/CA580X)
8-719-078-21 LED SML-310PTT86 (VOL4) (CA400)
8-719-053-09 LED SML-310VTT86 (VOL5)
(CA530X/CA580X)
8-719-078-21 LED SML-310PTT86 (VOL5) (CA400)
8-719-053-09 LED SML-310VTT86 (SOURCE)
(CA530X/CA580X)
8-719-078-21 LED SML-310PTT86 (SOURCE) (CA400)
8-719-053-09 LED SML-310VTT86 (VOL2)
(CA530X/CA580X)
8-719-078-21 LED SML-310PTT86 (VOL2) (CA400)
33
CDX-CA400/CA530X/CA580X
DISPLAY
Ref. No.
IN SELF SW
Part No.
Description
Remark
D587
8-719-053-09 LED SML-310VTT86 (VOL1)
D587
(CA530X/CA580X)
8-719-078-21 LED SML-310PTT86 (VOL1) (CA400)
< IC >
IC551
IC552
8-759-369-90 IC LC75822ED
8-749-017-35 IC KSM-401N
< JUMPER RESISTOR >
JR503
JR504
JR505
JR506
JR507
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
0
0
0
0
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
JR508
1-216-864-11 METAL CHIP
0
5%
1/16W
< LIQUID CRYSTAL DISPLAY >
LCD501 1-804-626-11 DISPLAY PANEL, LIQUID CRYSTAL
Ref. No.
Part No.
Description
R561
R562
R563
R564
R565
1-216-806-11
1-216-806-11
1-216-817-11
1-216-817-11
1-216-817-11
RES-CHIP
RES-CHIP
METAL CHIP
METAL CHIP
METAL CHIP
56
56
470
470
470
5%
5%
5%
5%
5%
Remark
1/16W
1/16W
1/16W
1/16W
1/16W
R566
R567
R568
R569
R570
1-216-817-11
1-216-817-11
1-216-817-11
1-216-817-11
1-216-817-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
470
470
470
470
470
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R571
R572
R573
R574
R575
1-216-817-11
1-216-817-11
1-216-817-11
1-216-817-11
1-216-817-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
470
470
470
470
470
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R576
R577
R578
R579
R580
1-216-817-11
1-216-817-11
1-216-817-11
1-216-817-11
1-216-817-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
470
470
470
470
470
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
< PILOT LAMP >
< SWITCH >
PL551
PL551
PL552
PL552
1-518-753-11 LAMP, PILOT (LCD BACK LIGHT) (CA400)
1-518-754-11 LAMP, PILOT (LCD BACK LIGHT)
(CA530X/CA580X)
1-518-753-11 LAMP, PILOT (LCD BACK LIGHT) (CA400)
1-518-754-11 LAMP, PILOT (LCD BACK LIGHT)
(CA530X/CA580X)
< RESISTOR >
R501
R502
R503
R504
R505
1-219-286-11
1-219-286-11
1-219-286-11
1-218-847-11
1-218-851-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
680
680
680
1K
1.5K
2%
2%
2%
2%
2%
1/16W
1/16W
1/16W
1/16W
1/16W
R506
R507
R508
R509
R510
1-218-851-11
1-218-855-11
1-218-859-11
1-218-863-11
1-218-867-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
1.5K
2.2K
3.3K
4.7K
6.8K
2%
2%
2%
2%
2%
1/16W
1/16W
1/16W
1/16W
1/16W
R511
R512
R513
R514
R515
1-219-286-11
1-219-286-11
1-219-286-11
1-218-847-11
1-218-851-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
680
680
680
1K
1.5K
2%
2%
2%
2%
2%
1/16W
1/16W
1/16W
1/16W
1/16W
R516
R517
R518
R519
R551
1-218-851-11
1-218-855-11
1-218-859-11
1-218-863-11
1-218-331-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
1.5K
2.2K
3.3K
4.7K
51K
2%
2%
2%
2%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R552
R554
R555
R559
R560
1-216-819-11
1-216-807-11
1-216-819-11
1-216-806-11
1-216-806-11
METAL CHIP
METAL CHIP
METAL CHIP
RES-CHIP
RES-CHIP
680
68
680
56
56
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
34
S501
S502
S503
S504
S505
1-572-704-31
1-572-704-31
1-572-704-31
1-572-704-31
1-572-704-31
SWITCH, KEYBOARD (Z)
SWITCH, KEYBOARD (OFF)
SWITCH, KEYBOARD (SOURCE)
SWITCH, KEYBOARD (MODE)
SWITCH, KEYBOARD (SEL)
S506
S507
S508
S509
S510
1-771-290-11
1-572-704-31
1-572-704-31
1-572-704-31
1-572-704-31
SWITCH, SLIDE (VOL)
SWITCH, KEYBOARD (ATT)
SWITCH, KEYBOARD (1/DISC –)
SWITCH, KEYBOARD (2/DISC +)
SWITCH, KEYBOARD (DSPL)
S511
S512
S513
S514
S515
1-572-704-31
1-572-704-31
1-771-290-11
1-572-704-31
1-572-704-31
SWITCH, KEYBOARD (MBP)
SWITCH, KEYBOARD (D-BASS)
SWITCH, SLIDE (SEEK/AMS)
SWITCH, KEYBOARD (BTM)
SWITCH, KEYBOARD (SENS)
S516
1-572-704-31 SWITCH, KEYBOARD (6)
S517
1-572-704-31 SWITCH, KEYBOARD (5)
S518
1-572-704-31 SWITCH, KEYBOARD (4/SHUF)
S519
1-572-704-31 SWITCH, KEYBOARD (3/REP)
*************************************************************
1-683-283-11 IN SELF SW BOARD
****************
< SWITCH >
SW2
1-529-566-31 SWITCH, PUSH (1 KEY) (SELF)
SW3
1-529-566-31 SWITCH, PUSH (1 KEY) (DISC IN)
*************************************************************
CDX-CA400/CA530X/CA580X
MAIN
Ref. No.
Part No.
Description
Remark
Part No.
Description
C608
C609
C610
C611
C612
1-164-156-11
1-162-970-11
1-104-396-11
1-162-927-11
1-162-927-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.01uF
10uF
100PF
100PF
10%
20%
5%
5%
25V
25V
16V
50V
50V
C613
C614
C615
C617
C618
1-162-927-11
1-164-174-11
1-165-176-11
1-165-176-11
1-162-964-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100PF
0.0082uF
0.047uF
0.047uF
0.001uF
5%
10%
10%
10%
10%
50V
25V
16V
16V
50V
16V
16V
16V
16V
50V
C619
C620
C621
C622
C623
1-162-964-11
1-104-665-11
1-104-396-11
1-162-911-11
1-162-912-11
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
0.001uF
100uF
10uF
6PF
7PF
10%
20%
20%
0.5PF
0.5PF
50V
10V
16V
50V
50V
C624
C625
C626
C627
C631
1-162-915-11
1-162-963-11
1-164-315-11
1-164-156-11
1-104-396-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
10PF
680PF
470PF
0.1uF
10uF
0.5PF
10%
5%
20%
50V
50V
50V
25V
16V
A-3283-245-A MAIN BOARD, COMPLETE (including
SPEAKER BOARD)
*********************
3-019-565-01
3-041-261-11
3-236-922-01
7-685-793-09
7-685-795-09
*
BRACKET (IC)
BRACKET (TR)
HEAT SINK
SCREW +PTT 2.6X8 (S)
SCREW +PTT 2.6X12 (S)
< CAPACITOR >
Ref. No.
Remark
C101
C102
C103
C104
C105
1-164-346-11
1-164-346-11
1-104-396-11
1-104-396-11
1-162-964-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP
1uF
1uF
10uF
10uF
0.001uF
C108
C110
C111
C113
C114
1-109-982-11
1-164-156-11
1-164-156-11
1-164-677-11
1-124-257-00
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
1uF
0.1uF
0.1uF
0.033uF
2.2uF
10%
20%
10V
25V
25V
16V
50V
C115
C116
C117
C118
C119
1-162-965-11
1-109-982-11
1-109-982-11
1-164-346-11
1-164-346-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.0015uF 10%
1uF
10%
1uF
10%
1uF
1uF
50V
10V
10V
16V
16V
C633
C650
C651
C652
C669
1-162-964-11
1-164-245-11
1-164-245-11
1-164-227-11
1-162-919-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.001uF
0.015uF
0.015uF
0.022uF
22PF
10%
10%
10%
10%
5%
50V
25V
25V
25V
50V
C120
C121
C201
C202
C203
1-164-346-11
1-162-964-11
1-164-346-11
1-164-346-11
1-104-396-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
1uF
0.001uF
1uF
1uF
10uF
16V
50V
16V
16V
16V
C671
C672
C701
C702
C703
1-162-970-11
1-162-970-11
1-124-584-00
1-124-584-00
1-124-584-00
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
ELECT
0.01uF
0.01uF
100uF
100uF
100uF
10%
10%
20%
20%
20%
25V
25V
10V
10V
10V
C204
C205
C208
C210
C211
1-104-396-11
1-162-964-11
1-109-982-11
1-164-156-11
1-164-156-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
10uF
0.001uF
1uF
0.1uF
0.1uF
20%
10%
10%
16V
50V
10V
25V
25V
C704
C706
C707
C801
C802
1-124-584-00
1-162-964-11
1-162-964-11
1-104-396-11
1-164-156-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
100uF
0.001uF
0.001uF
10uF
0.1uF
20%
10%
10%
20%
10V
50V
50V
16V
25V
C213
C214
C215
C216
C217
1-164-677-11
1-124-257-00
1-162-965-11
1-109-982-11
1-109-982-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.033uF
2.2uF
0.0015uF
1uF
1uF
10%
20%
10%
10%
10%
16V
50V
50V
10V
10V
C803
C804
C809
C810
C841
1-162-918-11
1-164-160-11
1-164-156-11
1-162-964-11
1-162-964-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
18PF
20PF
0.1uF
0.001uF
0.001uF
5%
5%
50V
50V
25V
50V
50V
C218
C219
C220
C221
C401
1-164-346-11
1-124-234-00
1-164-346-11
1-162-964-11
1-126-163-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT
1uF
22uF
1uF
0.001uF
4.7uF
C842
C846
C847
C848
C851
1-162-964-11
1-162-964-11
1-164-346-11
1-162-964-11
1-124-119-00
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
0.001uF
0.001uF
1uF
0.001uF
330uF
10%
10%
10%
20%
16V
16V
16V
50V
50V
C407
C426
C432
C435
C603
1-104-396-11
1-162-964-11
1-124-589-11
1-124-589-11
1-164-227-11
ELECT
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP
10uF
0.001uF
47uF
47uF
0.022uF
20%
10%
20%
20%
10%
16V
50V
16V
16V
25V
C869
C901
C904
C905
C907
1-162-970-11
1-135-473-21
1-126-160-11
1-164-156-11
1-164-156-11
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
0.01uF
3300uF
1uF
0.1uF
0.1uF
C604
C605
C606
1-162-970-11 CERAMIC CHIP
1-104-665-11 ELECT
1-104-665-11 ELECT
0.01uF
100uF
100uF
10%
20%
20%
25V
10V
10V
C909
C913
C914
1-164-156-11 CERAMIC CHIP
1-164-156-11 CERAMIC CHIP
1-104-665-11 ELECT
20%
20%
10%
10%
10%
20%
20%
0.1uF
0.1uF
100uF
10%
10%
10%
20%
10%
20%
20%
20%
50V
50V
16V
50V
16V
25V
16V
50V
25V
25V
25V
25V
10V
35
CDX-CA400/CA530X/CA580X
MAIN
Ref. No.
C915
C916
C919
C931
Part No.
Description
1-110-654-11
1-164-156-11
1-124-229-00
1-164-156-11
DOUBLE LAYERS
CERAMIC CHIP
ELECT
CERAMIC CHIP
Remark
0.047F
0.1uF
33uF
0.1uF
20%
5.5V
25V
10V
25V
< JACK >
CNJ601 1-793-598-11 JACK (ANTENNA)
< CONNECTOR >
CNJ801
CNP701
CNP801
CNP901
1-580-907-31
1-815-260-11
1-794-311-21
1-774-701-11
PLUG, CONNECTOR (BUS CONTROL IN)
CONNECTOR, BOARD TO BOARD 30P
PLUG, CONNECTOR 12P
PIN, CONNECTOR 16P
< SURGE ABSORBER >
CP601
1-803-335-21 ABSORBER, CHIP SURGE
Ref. No.
D933
D999
Part No.
Description
Remark
8-719-074-47 DIODE CRS02(TE85L)
8-719-991-33 DIODE 1SS133T-77
< IC >
IC101
IC401
IC601
IC801
IC802
8-759-827-14
8-759-827-11
8-759-586-59
6-801-302-01
8-759-096-16
IC
IC
IC
IC
IC
TA8268AH
LC75421M-TLM-E
TB2118F-EL-S
uPD780076GK-520-9ET
MM1175XFF
IC902
8-759-837-07 IC S7139SF
< JUMPER RESISTOR >
JR110
JR603
JR605
JR606
JR607
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
0
0
0
0
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
JR903
JR904
JR929
1-216-864-11 METAL CHIP
1-216-864-11 METAL CHIP
1-216-864-11 METAL CHIP
0
0
0
5%
5%
5%
1/16W
1/16W
1/16W
< DIODE >
D401
D402
D444
D604
D802
8-719-991-33
8-719-988-61
8-719-988-61
8-719-109-85
8-719-109-97
DIODE
DIODE
DIODE
DIODE
DIODE
1SS133T-77
1SS355TE-17
1SS355TE-17
RD5.1ES-B2
RD6.8ES-B2
D803
D804
D805
D806
D807
8-719-109-97
8-719-109-97
8-719-109-97
8-719-109-97
8-719-109-97
DIODE
DIODE
DIODE
DIODE
DIODE
RD6.8ES-B2
RD6.8ES-B2
RD6.8ES-B2
RD6.8ES-B2
RD6.8ES-B2
D808
D809
D851
D852
D853
8-719-109-97
8-719-109-97
8-719-420-51
8-719-017-95
8-719-017-95
DIODE
DIODE
DIODE
DIODE
DIODE
RD6.8ES-B2
RD6.8ES-B2
MA729
MA8180-TX
MA8180-TX
D854
D901
D903
D907
D908
8-719-109-97
8-719-049-38
8-719-977-12
8-719-110-49
8-719-921-63
DIODE
DIODE
DIODE
DIODE
DIODE
RD6.8ES-B2
1N5404TU
DTZ6.8B
RD18ES-B2
MTZJ-7.5B
D909
D910
D913
D915
D916
8-719-109-97
8-719-109-89
8-719-110-14
8-719-110-49
8-719-110-49
DIODE
DIODE
DIODE
DIODE
DIODE
RD6.8ES-B2
RD5.6ES-B2
RD9.1ES-B3
RD18ES-B2
RD18ES-B2
D917
D918
D919
D920
D921
8-719-110-49
8-719-110-49
8-719-053-18
8-719-053-18
8-719-110-49
DIODE
DIODE
DIODE
DIODE
DIODE
RD18ES-B2
RD18ES-B2
1SR154-400TE-25
1SR154-400TE-25
RD18ES-B2
D922
D923
D930
D931
D932
8-719-110-49
8-719-110-14
8-719-109-89
8-719-988-61
8-719-988-61
DIODE
DIODE
DIODE
DIODE
DIODE
RD18ES-B2
RD9.1ES-B3
RD5.6ES-B2
1SS355TE-17
1SS355TE-17
< COIL >
L601
L603
L604
L669
L701
1-410-508-11
1-412-006-31
1-410-750-41
1-424-759-21
1-410-513-11
L702
L703
L901
1-410-513-11 INDUCTOR
1-410-513-11 INDUCTOR
1-419-476-31 COIL, CHOKE
8.2uH
10uH
0.47uH
22uH
22uH
22uH
250uH
< JACK >
PJ401
36
INDUCTOR
INDUCTOR
INDUCTOR
COIL (AM ANT)
INDUCTOR
1-774-699-12 JACK, PIN 4P (AUDIO OUT REAR,
BUS AUDIO IN)
< TRANSISTOR >
Q101
Q102
Q201
Q202
Q401
8-729-920-21
8-729-920-21
8-729-920-21
8-729-920-21
8-729-055-92
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTC314TK-T-146
DTC314TK-T-146
DTC314TK-T-146
DTC314TK-T-146
SRA2203SF
Q402
Q603
Q604
Q605
Q606
8-729-055-96
8-729-030-51
8-729-055-96
8-729-030-51
8-729-055-96
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
SRC1203SF
2SA1515S-R-TP
SRC1203SF
2SA1515S-R-TP
SRC1203SF
Q902
Q904
Q905
Q906
Q907
8-729-049-40
8-729-055-96
8-729-055-96
8-729-055-92
8-729-019-00
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC5343SFG
SRC1203SF
SRC1203SF
SRA2203SF
2SD2394-G
Q909
8-729-055-96 TRANSISTOR SRC1203SF
CDX-CA400/CA530X/CA580X
MAIN
Ref. No.
Part No.
Description
Part No.
Description
Q910
Q911
Q912
Q913
Q914
8-729-920-85
8-729-055-96
8-729-055-92
8-729-019-00
8-729-055-96
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SD1664-QR
SRC1203SF
SRA2203SF
2SD2394-G
SRC1203SF
Remark
R618
R619
R620
R622
R628
1-216-845-11
1-216-817-11
1-216-817-11
1-216-817-11
1-216-829-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
470
470
470
4.7K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
Q915
Q917
Q918
Q919
Q920
8-729-049-43
8-729-820-46
8-729-055-92
8-729-920-85
8-729-920-85
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
STB1132Y
2SB1202FAS
SRA2203SF
2SD1664-QR
2SD1664-QR
R704
R705
R706
R707
R708
1-216-821-11
1-216-821-11
1-216-864-11
1-247-887-00
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
CARBON
METAL CHIP
1K
1K
0
220K
1K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/4W
1/16W
Q921
Q929
8-729-055-96 TRANSISTOR SRC1203SF
8-729-055-96 TRANSISTOR SRC1203SF
R709
R710
R711
R712
R714
1-216-821-11
1-216-821-11
1-216-821-11
1-216-821-11
1-216-825-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
1K
1K
2.2K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R716
R806
R807
R808
R809
1-216-825-11
1-216-821-11
1-216-821-11
1-216-821-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
1K
1K
1K
1K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R810
R811
R812
R813
R814
1-216-813-11
1-249-409-11
1-249-409-11
1-216-837-11
1-216-809-11
METAL CHIP
CARBON
CARBON
METAL CHIP
METAL CHIP
220
220
220
22K
100
5%
5%
5%
5%
5%
1/16W
1/4W
1/4W
1/16W
1/16W
R815
R819
R821
R824
R835
1-216-809-11
1-216-864-11
1-216-849-11
1-216-849-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
0
220K
220K
1K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R840
R844
R845
R846
R847
1-216-821-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
100
100
100
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R848
R849
R851
R852
R853
1-216-809-11
1-216-809-11
1-249-421-11
1-216-809-11
1-247-807-31
METAL CHIP
METAL CHIP
CARBON
METAL CHIP
CARBON
100
100
2.2K
100
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/4W
1/16W
1/4W
R854
R855
R901
R905
R906
1-216-841-11
1-216-821-11
1-249-425-11
1-216-864-11
1-216-821-11
METAL CHIP
METAL CHIP
CARBON
METAL CHIP
METAL CHIP
47K
1K
4.7K
0
1K
5%
5%
5%
5%
5%
1/16W
1/16W
1/4W
1/16W
1/16W
R907
R908
R909
R911
R912
1-216-841-11
1-216-841-11
1-216-828-11
1-249-417-11
1-249-413-11
METAL CHIP
METAL CHIP
METAL CHIP
CARBON
CARBON
47K
47K
3.9K
1K
470
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/4W
1/4W
R913
R917
R918
1-249-417-11 CARBON
1-249-409-11 CARBON
1-216-845-11 METAL CHIP
1K
220
100K
5%
5%
5%
1/4W
1/4W
1/16W
< RESISTOR >
R107
R108
R109
R110
R113
1-216-841-11
1-216-841-11
1-216-809-11
1-216-809-11
1-218-867-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
RES-CHIP
47K
47K
100
100
6.8K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R115
R121
R122
R207
R208
1-216-834-11
1-216-821-11
1-216-841-11
1-216-841-11
1-216-841-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
12K
1K
47K
47K
47K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R209
R210
R213
R215
R221
1-216-809-11
1-216-809-11
1-218-867-11
1-216-834-11
1-216-821-11
METAL CHIP
METAL CHIP
RES-CHIP
METAL CHIP
METAL CHIP
100
100
6.8K
12K
1K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R222
R401
R404
R407
R408
1-216-841-11
1-216-833-11
1-216-821-11
1-249-437-11
1-218-867-11
METAL CHIP
METAL CHIP
METAL CHIP
CARBON
RES-CHIP
47K
10K
1K
47K
6.8K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/4W
1/16W
R410
R444
R601
R602
R603
1-216-805-11
1-216-864-11
1-249-417-11
1-216-821-11
1-249-407-11
METAL CHIP
METAL CHIP
CARBON
METAL CHIP
CARBON
47
0
1K
1K
150
5%
5%
5%
5%
5%
1/16W
1/16W
1/4W
1/16W
1/4W
R604
R605
R606
R607
R608
1-216-821-11
1-216-841-11
1-216-841-11
1-216-827-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
47K
47K
3.3K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R609
R610
R611
R612
R613
1-216-809-11
1-216-809-11
1-218-867-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
RES-CHIP
METAL CHIP
METAL CHIP
100
100
6.8K
10K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R614
R615
R616
R617
1-247-807-31
1-216-825-11
1-216-845-11
1-216-825-11
CARBON
METAL CHIP
METAL CHIP
METAL CHIP
100
2.2K
100K
2.2K
5%
5%
5%
5%
1/4W
1/16W
1/16W
1/16W
Ref. No.
Remark
37
CDX-CA400/CA530X/CA580X
MAIN
Ref. No.
SERVO
Part No.
Description
Remark
Ref. No.
Part No.
Description
R919
R920
R922
R923
R924
1-249-421-11
1-216-849-11
1-208-806-11
1-208-806-11
1-249-404-00
CARBON
METAL CHIP
RES-CHIP
RES-CHIP
CARBON
2.2K
220K
10K
10K
82
5%
5%
0.5%
0.5%
5%
1/4W
1/16W
1/10W
1/10W
1/4W
C19
C20
C21
C22
C23
1-107-826-11
1-107-826-11
1-162-970-11
1-162-970-11
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.01uF
0.01uF
0.01uF
10%
10%
10%
10%
10%
16V
16V
25V
25V
25V
R925
R926
R927
R928
R929
1-249-404-00
1-249-404-00
1-249-404-00
1-249-404-00
1-249-404-00
CARBON
CARBON
CARBON
CARBON
CARBON
82
82
82
82
82
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
C24
C25
C26
C27
C29
1-162-970-11
1-162-970-11
1-126-391-11
1-162-970-11
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.01uF
47uF
0.01uF
0.01uF
10%
10%
20%
10%
10%
25V
25V
6.3V
25V
25V
R930
R931
R932
R933
R934
1-249-395-11
1-218-867-11
1-249-421-11
1-216-821-11
1-249-409-11
CARBON
RES-CHIP
CARBON
METAL CHIP
CARBON
15
6.8K
2.2K
1K
220
5%
5%
5%
5%
5%
1/4W
1/16W
1/4W
1/16W
1/4W
C30
C34
C35
C36
C37
1-162-970-11
1-162-970-11
1-162-970-11
1-162-970-11
1-126-393-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
0.01uF
0.01uF
0.01uF
0.01uF
33uF
10%
10%
10%
10%
20%
25V
25V
25V
25V
10V
C38
C40
C41
C43
C44
1-162-970-11
1-107-826-11
1-162-970-11
1-162-967-11
1-125-837-91
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.1uF
0.01uF
0.0033uF
1uF
10%
10%
10%
10%
10%
25V
16V
25V
50V
6.3V
C45
1-162-970-11 CERAMIC CHIP
0.01uF
10%
25V
< SWITCH >
S901
1-762-638-11 SWITCH, TACTILE (RESET)
< THERMISTOR (POSITIVE) >
TH851
TH901
1-801-792-21 THERMISTOR, POSITIVE
1-809-148-11 THERMISTOR PTH8L07AR2R0M1B510
Remark
< CONNECTOR >
< TUNER >
TU601
CN1
CN3
A-3220-835-A TUNER UNIT (TUX-010)
1-815-352-11 CONNECTOR, BOARD TO BOARD 30P
1-816-275-11 CONNECTOR, FFC/FPC 6P
< VIBRATOR >
< JUMPER RESISTOR >
X601
1-781-246-21 VIBRATOR, CRYSTAL (10.25MHz)
X801
1-795-259-11 VIBRATOR, CERAMIC (8.38MHz)
X802
1-567-098-41 VIBRATOR, CRYSTAL (32kHz)
*************************************************************
A-3283-233-A SERVO BOARD, COMPLETE
**********************
FB1
FB2
FB3
FB4
FB6
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
0
0
0
0
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
FB7
1-216-864-11 METAL CHIP
0
5%
1/16W
1-683-284-11 FLEXIBLE BOARD
< IC >
< CAPACITOR >
IC1
IC2
C1
C3
C4
C5
C6
1-162-970-11
1-162-970-11
1-104-609-11
1-162-970-11
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.01uF
100uF
0.01uF
0.01uF
10%
10%
20%
10%
10%
25V
25V
4V
25V
25V
C8
C9
C10
C11
C13
1-107-826-11
1-162-924-11
1-162-924-11
1-162-909-11
1-162-916-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
56PF
56PF
4PF
12PF
10%
5%
5%
0.25PF
5%
16V
50V
50V
50V
50V
C14
C15
C16
C17
C18
1-125-837-91
1-162-970-11
1-162-970-11
1-162-970-11
1-162-966-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
1uF
0.01uF
0.01uF
0.01uF
0.0022uF
10%
10%
10%
10%
10%
6.3V
25V
25V
25V
50V
8-759-699-98 IC uPD63711GC-8EU
8-759-658-87 IC BA5810FP-E2
< TRANSISTOR >
Q1
8-729-904-87 TRANSISTOR 2SB1197K-R
< RESISTOR >
38
R3
R5
R6
R7
R8
1-216-797-11
1-218-344-11
1-216-837-11
1-216-839-11
1-216-833-11
METAL CHIP
RES-CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10
7.5K
22K
33K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R9
R10
R12
R14
R15
1-216-840-11
1-216-835-11
1-216-837-11
1-216-841-11
1-216-841-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
39K
15K
22K
47K
47K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
CDX-CA400/CA530X/CA580X
SERVO
Ref. No.
Part No.
Description
R17
R18
R19
R20
R21
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
100
1K
5%
5%
5%
5%
5%
Remark
1/16W
1/16W
1/16W
1/16W
1/16W
R22
R24
R25
R26
R29
1-216-821-11
1-216-864-11
1-216-864-11
1-216-797-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
0
0
10
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R30
1-216-833-11 METAL CHIP
10K
5%
1/16W
< SWITCH >
SW1
1-762-944-12 SWITCH, DETECTION (SMALL TYPE) (DOWN)
Ref. No.
Part No.
SL SW
SPEAKER
Description
Remark
ACCESSORIES
************
1-476-526-31 REMOTE COMMANDER (RM-X115)
(CA400/CA580X)
3-230-047-01 LID, BATTERY CASE (for RM-X115)
(CA400/CA580X)
3-238-717-11 MANUAL, INSTRUCTION, INSTALL
(ENGLISH,FRENCH) (CA400)
3-238-719-11 MANUAL, INSTRUCTION (ENGLISH,FRENCH)
(CA400)
3-238-722-11 MANUAL, INSTRUCTION, INSTALL
(ENGLISH,SPANISH) (CA530X/CA580X)
3-238-723-11 MANUAL, INSTRUCTION (ENGLISH,SPANISH)
(CA530X/CA580X)
X-3380-054-2 CASE ASSY (for FRONT PANEL)
*************************************************************
< VIBRATOR >
PARTS FOR INSTALLATION AND CONNECTIONS
**************************************
X1
1-795-520-21 VIBRATOR, CERAMIC (16.9344MHz)
*************************************************************
1-683-282-11 SL SW BOARD
************
< SWITCH >
SW4
1-529-565-41 SWITCH, PUSH (1 KEY) (LIMIT)
*************************************************************
1-683-830-11 SPEAKER BOARD (supplied with
MAIN BOARD, COMPLETE)
**************
*************************************************************
251
252
3-014-370-21 FRAME, FITTING
X-3366-405-1 SCREW ASSY (EXP), FITTING
253
254
255
3-934-325-01 SCREW (+K 5X8 TP)
3-030-929-04 SPRING, FITTING
3-236-923-01 COLLAR
256
1-776-206-21 CORD (WITH CONNECTOR) (POWER)
(CA530X/CA580X)
251
252
MISCELLANEOUS
***************
3
201
207
0 210
F901
1-776-206-21
X-3378-480-1
1-823-641-11
8-820-103-11
1-532-877-11
CORD (WITH CONNECTOR) (POWER)
CHASSIS (OP) ASSY (including M901)
CABLE, FLEXIBLE FLAT (6 CORE)
PICK-UP, OPTICAL KSS-720A/C-RP
FUSE (BLADE TYPE) (AUTO FUSE) 10A
253
254
255
256
M902
A-3301-985-A MOTOR ASSY, SLED (SLED)
M903
A-3315-039-A MOTOR SUB ASSY, LO (LOADING)
*************************************************************
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
Les composants identifiés par une
marque 0 sont critiques pour
la sécurité.
Ne les remplacer que par une piéce
portant le numéro spécifié.
39
CDX-CA400/CA530X/CA580X
REVISION HISTORY
Clicking the version allows you to jump to the revised page.
Also, clicking the version at the upper right on the revised page allows you to jump to the next revised
page.
Ver.
1.0
40
Date
2001. 12
Description of Revision
New