Download Massey Ferguson L&G BARON 1693583 User's Manual
Transcript
Parts Manual BARON SERIES LAWN TRACTORS & MOWER DECKS 18HP V-TWIN TRACTORS Mfg. No. Description 1693583 1693494 1693686 18V HP Baron 18V HP Baron (Export) 18V HP Baron (Export) MOWER DECKS Mfg. No. Description 1693554 1693560 1693585 1693575 40” Mower Deck 40” Mower Deck 40” Mower Deck 102 cm Mower Deck (Export) Rev. 7/2001 TP 400-2275-02-BR-S MANUFACTURING, INC. 500 N Spring Street / PO Box 997 Port Washington, WI 53074-0997 USA © Copyright 1999 Simplicity Manufacturing, Inc. All Rights Reserved. Printed In USA. Table of Contents This Manual Covers The Following Products: LAWN TRACTOR COMPONENTS 18HP LAWN TRACTORS PAGES Frame & Front Axle Group . . . . . . . . . . . . . . . . . . . . . .2 1693583 Baron, 18HP 1693494 Baron, 18HP (Export) 1693686 Baron, 18HP (Export) 2, 4, 8, 10, 14, 16, 18, 20, 22, 24, 26, 28, 30, 32. Steering Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4 Engine Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6 Transmission Drive & Carrier Group . . . . . . . . . . . . . .8 Transmission Service Parts - 40" (102 cm) MOWER DECKS PAGES Tuff Torq K51 Transaxle . . . . . . . . . . . . . . . . . . . . . .10 1693554 1693560 1693585 1693575 34, 36, 38, 40, 42, 44, 46. Foot Controls Group . . . . . . . . . . . . . . . . . . . . . . . . .14 40" Mower Deck 40” Mower Deck 40" Mower Deck 102 cm Mower Deck (Export) Hand Controls Group . . . . . . . . . . . . . . . . . . . . . . . . .16 Hood, Grille & Dash Group . . . . . . . . . . . . . . . . . . . .18 Seat, Seat Deck & Fuel Tank Group . . . . . . . . . . . . . .20 Hopper Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22 Electrical Group – Lower Harness . . . . . . . . . . . . . . .24 Electrical Group – Upper Harness . . . . . . . . . . . . . . .26 Wheels & Tires Group . . . . . . . . . . . . . . . . . . . . . . . .28 Decals Group . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .30 Decals Group (Export) . . . . . . . . . . . . . . . . . . . . . . . .32 MOWER DECK COMPONENTS 40" (102 cm) Mower Deck - Housing, Arbors & Blades (Serial No. 0001-1999) . . . . . . . . . . . . . . . . . . . . . . .34 40" (102 cm) Mower Deck - Housing, Arbors & Blades (Serial No. 2000-2999) . . . . . . . . . . . . . . . . . . . . . . .36 40" (102 cm) Mower Deck - Housing, Arbors & Blades (Serial No. 3000 and above) . . . . . . . . . . . . . . . . . . .38 40" (102 cm) Mower Deck - Belt, Clutch & Support (Serial No. 0001-1999) . . . . . . . . . . . . . . . . . . . . . . .40 40" (102 cm) Mower Deck - Belt, Clutch & Support (Serial No. 2000 and above) . . . . . . . . . . . . . . . . . . .42 40" (102 cm) Mower Deck Height Adjustment & Rollers - (Earlier Models) . . . . .44 40" (102 cm) Mower Deck Height Adjustment & Rollers - (Later Models) . . . . . .46 REFERENCE INFORMATION: Part Number Index . . . . . . . . . . . . . . . . . . . . . . . . . .48 Torque Specification Chart . . . . . . . . .Inside Back Cover © Copyright 2001 Simplicity Manufacturing, Inc. All Rights Reserved. TP 400-2275-02-BR-S 1 Frame & Front Axle Group 985544 NOTE: Unless noted otherwise, use the standard hardware torque specification chart. 34 35 36 35 7 3 8 9 6 4 10 11 12 9 13 5 14 15 35 16 17 8 18 13 19 16 1 2 21 20 24 22 25 23 27 29 29 28 26 30 29 Point hook to outside 31 34 31 32 Torque to 70-90 ft. lbs. 33 The above parts group applies to the following Mfg. Nos.: 1693583 1693494 1693686 Baron, 18HP Tractor Baron, 18HP Tractor (Export) Baron, 18HP Tractor (Export) © Copyright 2001 Simplicity Manufacturing, Inc. All Rights Reserved. 2 TP 400-2275-02-BR-S Frame & Front Axle Group REF NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 PART NO. QTY. 1717936 1719355 1720041 1960373 1719966 1722092 1721171 1666697 1721172 1719731 1960590 1919326 1930601 1713447 1927557 1960074 1708298 1960043 1721169 1916950 1916965 1935041 1704351 1719972 1931350 1704311 1931277 1679385 1960270 960530 1704314 176440 1703475 1718856 1916951 1721174 1 1 2 4 1 1 1 2 2 2 2 2 9 2 2 4 2 4 1 2 2 4 13 1 2 1 2 1 1 2 2 4 1 1 4 1 DESCRIPTION PAD, Footrest, R H FRAME ASSEMBLY STRAP, Fuel Tank CAPSCREW, Hex Washer Head, Taptite, 5/16-18 x 1 SUPPORT, Brace BACKPLATE, Grass Bag BRACKET & PIVOT ASSEMBLY, R H Cylinder SPACER SUPPORT, Hopper LATCH, Support CAPSCREW, Hex Head, 5/16-18 x 3 WASHER, Flat, 5/16 CAPSCREW, Hex Washer Head, Taptite, 5/16-18 x 3/4 SPACER NUT, Hex Flange Whizlock, 5/16-18 CLIP, Hair Pin PIN, Round Head Drilled, 3/8 X 1 CAPSCREW, Hex Flange Whizlock, 7/16-14 x 1 BRACKET & PIVOT ASSEMBLY, L H Cylinder NUT, Hex, 3/8-16 LOCKWASHER, Spring, 3/8 NUT, Hex Flange Whizlock, 7/16-14 FASTENER, Panel DRAWBAR CARRIAGE BOLT, 3/8-16 x 1 PAD, Footrest, L H NUT, Hex Flange 5/16-18 HOOK-J NUT, Hex Full Lock, 3/4-16 WASHER, Special, 7/8 x 1-3/4 x 1/16 FITTING, Grease BUSHING, Nylon AXLE ASSEMBLY, Front SHAFT & LOCK ASSEMBLY, Axle Pivot NUT, Hex 1/2-13 ROD, Support Footnotes: The above parts group applies to the following Mfg. Nos.: 1693583 1693494 1693686 Baron, 18HP Tractor Baron, 18HP Tractor (Export) Baron, 18HP Tractor (Export) TP 400-2275-02-BR-S 3 Steering Group 985647 NOTE: Unless noted otherwise, use the standard hardware torque specification chart. 4 3 5 6 7 2 8 1 9 13 Coat gear teeth with grease 30 11 20 34 30 32 27 11 Grease 2-Bushings 29 36 Torque to 36-44 ft. lbs. (2 places) 33 20 26 28 26 10 6 14 29 31 11 12 16 35 6 27 17 24 21 22 16 23 22 21 18 19 Note: To index wheel - loosen nuts 20 Ref. #22 & #10 and troque 22 to 40 18 ft. lbs. (for nut #10 torque to 36-44 ft. 19 15 See Wheels & Tires 25 The above parts group applies to the following Mfg. Nos.: 1693583 1693494 1693686 Baron, 18HP Tractor Baron, 18HP Tractor (Export) Baron, 18HP Tractor (Export) © Copyright 2001 Simplicity Manufacturing, Inc. All Rights Reserved. 4 TP 400-2275-02-BR-S Steering Group REF NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 PART NO. QTY. 1714400 1960540 1719471 1719810 1919314 1960114 1960529 1931350 1703508 1928352 176440 1720122 1921221 1703513 1921968 1673796 1919438 1708236 1922755 1930645 1702779 1919262 1708084 1685478 1715308 1921968 1611705 1706997 1960020 1704420 1706956 1706996 1960373 1928721 1928721 930670 1 1 1 1 1 7 1 2 1 2 3 1 1 1 2 1 1 2 2 4 2 2 1 1 2 2 2 1 2 2 1 1 2 2 1 1 DESCRIPTION TUBE, Flexible Black Rubber PIN, Spring, 5/16 x 2-1/2 WHEEL, Steering CAP, Steering Wheel PIN, Cotter, 3/16 x 1-1/4 WASHER, 3/4 WASHER, Plain, 1 x 1-1/2 x .07 CARRIAGE BOLT, 3/8-16 x 1 PLATE, Mounting, Steering NUT, Hex Flange Whizlock, 3/8-16 BUSHING, Nylon SHAFT & GEAR ASSEMBLY, Steering CAPSCREW, Hex Head, 5/16-18 x 1-1/2 GEAR & HUB ASSEMBLY, Steering CAPSCREW, Hex Head, 3/8-16 x 1-3/8 SPACER NUT, Hex Lock ESNA Light, 5/16-18 SPACER WASHER, 3/8 NUT, Hex Flange Two-Way Lock, 3/8-16 JOINT, Ball NUT, Hex Jam 1/2-20 DRAG LINK DRAG LINK ASSEMBLY, (Includes Ref. Nos. 21, 22 & 23) SPINDLE ASSEMBLY CAPSCREW, 3/8-16x x1-3/8 SPACER STEERING ARM ASSEMBLY, L H WASHER KLIPRING, 5/8 TIE ROD STEERING ARM ASSEMBLY, R H CAPSCREW, Hex Head,Taptite, 5/16-18 x 1 SET SCREW, Square Head, 5/16- 18 x 1/2 PITMAN ARM ASSEMBLY KEY, Hi-Pro Footnotes: The above parts group applies to the following Mfg. Nos.: 1693583 1693494 1693686 Baron, 18HP Tractor Baron, 18HP Tractor (Export) Baron, 18HP Tractor (Export) TP 400-2275-02-BR-S 5 Engine Group 985543A_985707 NOTE: Unless noted otherwise, use the standard hardware torque specification chart. Heat to 100˚ F for installation 12 10 13 11 14 Coat threads with pipe sealent 42 9 10 8 Torque to 35-45 in. lbs. 7 15 6 5 4 2 1 3 16 17 37 39 Apply anti-seize lubricant to crankshaft 19 18 20 41 Torque (4) engine mounting blots to 28-34 ft. lbs. 30 38 21 37 22 36 35 41 34 32 33 40 Note: Orentation of Keys 29 28 31 Mount exhaust manifold and torque screws to 175-200 in. lbs. 27 25 23 26 Torque to 45-50 ft. lbs. 24 The above parts group applies to the following Mfg. Nos.: 1693583 1693494 1693686 Baron, 18HP Tractor Baron, 18HP Tractor (Export) Baron, 18HP Tractor (Export) © Copyright 2001 Simplicity Manufacturing, Inc. All Rights Reserved. 6 TP 400-2275-02-BR-S Engine Group REF NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 PART NO. QTY. 934683 1960295 1707334 1960624 1720507 1667346 1673453 1720017 * 960112 1718678 1713846 1714068 1721446 1960536 1708764 920427 930598 1704419 1924940 1930598 1713187 105337 1720532 1960370 1918199 1708264 172434 1720110 1936228 1919326 1676183 1931342 1704357 1960368 1720109 1935255 1917356 1917372 1921333 1721202 1919326 1721987 1 4 1 1 1 1 1 1 1 2 1 1 1 1 2 1 1 1 1 1 3 1 1 1 1 1 1 1 1 4 2 1 1 1 4 1 1 6 1 1 1 2 1 DESCRIPTION CLIP, Speed Wire CAPSCREW, Hex Flange Whizlock, 1/4-20 x 5/8 DUCT, Muffler, Top CAPSCREW, Pan Head, Torx, #10-32 x 1/2 (Early Models) BRACKET, Flat (Early Models) CAP, Hex, 3/8-18NPT FITTING, Pipe Elbow Street PIPE, Oil Drain ENGINE, 18.0HP B&S INTEK CLAMP, Hose, 1/2 Diameter Type E HOSE, Fuel KNOB, Soft CONTROL, Throttle 3/16 Cable 35-3/4 Long, No Knob CONTROL, Throttle 3/16 Cable 35-3/4 Long, No Knob (Export) CAPSCREW, Hex Washer Head, 1/4 x 1/2 CONTROL, Choke 3/16 Cable 39-1/2 Long w/Knob LOCKWASHER, External Tooth, 3/8 CAPSCREW, Hex Washer Head, Taptite, 3/8-16 x 1-1/2 STOP, Belt WASHER, 3/8 CAPSCREW, Hex Washer Head, Taptite, 3/8-16 x 1-1/2 PULLEY & HUB ASSEMBLY KEY, HI PRO, 1/4 x 2.000 CLUTCH, Electric CAPSCREW, Hex Head, 7/16-20 x 2-1/2 LOCKWASHER, Spring, 7/16 WASHER, Hex CLIP, Speed Wire MANIFOLD, Exhaust CAPSCREW, Hex Head, 5/16-18 x 3/4 G8 WASHER, 5/16 CLAMP, Exhaust CARRIAGE BOLT, 5/16-18 x 2-3/4 DUCT, Muffler, Bottom NUT, Speed, 1/4-20 Lug MUFFLER NUT, Speed, 5/16-18 LUG LOCKWASHER, Spring, 5/16 NUT, Hex, 5/16-18 CAPSCREW, Hex Head, 5/16-18 x 1.000 BAFFLE, Muffler WASHER, 5/16 DECAL, 18HP Brigga & Stratton INTEK Footnotes: * Contact your Briggs & Stratton distributor for repair parts. The above parts group applies to the following Mfg. Nos.: 1693583 1693494 1693686 Baron, 18HP Tractor Baron, 18HP Tractor (Export) Baron, 18HP Tractor (Export) TP 400-2275-02-BR-S 7 Transmission Drive & Carrier Group - Tuff Torq Model K51 985545 NOTE: Unless noted otherwise, use the standard hardware torque specification chart. 2 9 6 3 10 11 8 4 13 12 3 11 3 5 7 1 See Foot Controls 14 15 16 17 24 25 18 19 26 27 38 28 39 With brake pedal locked, spring to be compressed to 3-3/8in. 22 40 9 10 42 28 30 3 37 21 29 29 35 36 41 46 20 23 3 28 34 11 37 1 3 3 12 40 8 45 17 3 16 28 44 28 41 33 3 6 43 31 32 The above parts group applies to the following Mfg. Nos.: 1693583 1693494 1693686 Baron, 18HP Tractor Baron, 18HP Tractor (Export) Baron, 18HP Tractor (Export) © Copyright 2001 Simplicity Manufacturing, Inc. All Rights Reserved. 8 TP 400-2275-02-BR-S Transmission Drive & Carrier Group - Tuff Torq Model K51 REF NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 PART NO. QTY. 1720019 1923325 1919326 1703900 1935048 1719268 1921210 1931352 1916950 1916965 1924940 174561 1922127 1935048 1960223 1917372 1917356 1919381 1719993 1960613 1916964 1960353 1719902 927794 176440 106681 1717425 1918447 1930810 1719312 1960590 1719269 1921719 1720108 1922694 1714255 1706553 1720018 1720022 1924874 1919438 1663136 1719253 1666697 1931335 1720036 1 1 12 1 1 1 1 2 2 2 6 2 1 4 1 2 2 1 1 1 1 1 1 2 2 1 1 5 3 1 2 1 2 1 1 1 1 1 1 1 2 1 1 1 1 1 DESCRIPTION ROD, Front Brake CAPSCREW, Hex Head, 5/16-18 x 7/8 WASHER SPACER NUT, Hex Flange Two-Way Lock, 5/16-18 ROD, Pedal CAPSCREW, Hex Head, 3/8-16 x 1 CARRIAGE BOLT, 3/8-16 x 1-1/2 NUT, Hex, 3/8-16 LOCKWASHER, 3/8 WASHER, 3/8 PULLEY CAPSCREW, Hex Head, 5/16-18 x 1-3/4 NUT, Hex Flange Two-Way Lock, 5/16-18 CARRIAGE BOLT, 5/16-18 x 1-1/4 NUT, Hex, 5/16-18 LOCKWASHER, 5/16 WASHER GUIDE, Belt CAPSCREW, Hex Head, M06-1.00 x 20MM 8.8 LOCKWASHER, 1/4 WASHER, 1/4 PULLEY & HUB ASSEMBLY RING-E BUSHING, Nylon SPRING, Extension FAN PIN, Cotter, 3/32 x 3/4 CAPSCREW, Hex Washer Head Taptite, 1/4-20 x 1-1/2 ROD, Dump Valve CAPSCREW, Hex Head, 5/16-18 x 3 ROD, Transmission CAPSCREW, Hex Head, 5/16-18 x 2-1/2 TRANSMISSION ASSEMBLY, Tuff Torq K51 NUT, Hex Lock ESNA Heavy, 3/8-16 SPACER SPRING, Extension ROD, Rear Brake ARM, Brake Pivot WASHER NUT, Hex Lock ESNA Light, 5/16-18 SPRING, Compression SHAFT & ARMS ASSEMBLY SPACER CARRIAGE BOLT, 5/16-18X1 V-BELT Footnotes: The above parts group applies to the following Mfg. Nos.: 1693583 1693494 1693686 Baron, 18HP Tractor Baron, 18HP Tractor (Export) Baron, 18HP Tractor (Export) TP 400-2275-02-BR-S 9 Transmission Service Parts - Tuff Torq K51 Transaxle 1720108 NOTE: Unless noted otherwise, use the standard hardware torque specification chart. 61 23 13 12 24 15 25 8 5 62 7 64 52 63 3 97 76 51 4 65 79 23 78 50 53 49 14 77 39 76 41 63 54 48 55 47 10 43 46 38 37 44 11 34 42 45 37 35 40 36 22 74 29 32 28 33 18 72 64 39 70 31 67 75 65 71 68 69 73 62 60 26 66 29 19 21 20 56 57 32 31 30 27 59 54 6 1 16 37 31 58 57 17 37 The above parts group applies to the following Mfg. Nos.: 1693583 1693494 1693686 Baron, 18HP Tractor Baron, 18HP Tractor (Export) Baron, 18HP Tractor (Export) © Copyright 2001 Simplicity Manufacturing, Inc. All Rights Reserved. 10 TP 400-2275-02-BR-S Transmission Service Parts - Tuff Torq K51 Transaxle REF NO. PART NO. QTY. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 1721176 1718052 1718053 1718054 1718055 1707789 1720417 1720418 1708691 1720419 1718061 1708651 1708650 1720420 1707839 1708649 1708653 1721177 1718070 1718071 1708667 1718073 1720424 1708673 1718076 1718077 1718078 1718079 1718080 1718081 1720425 1718083 1718084 1720426 1718086 1718087 1718088 1718089 1718120 1721178 1 1 1 1 1 20 1 1 2 1 1 1 1 1 1 2 2 1 1 1 3 1 1 1 2 1 1 1 1 1 1 1 1 1 1 1 1 2 2 1 41 42 43 44 45 46 47 48 1721179 1721965 1721181 1721182 1718097 1721966 1707912 1721184 1 1 1 1 1 1 1 1 DESCRIPTION HOUSING, LOWER TUFF TORQ VENT VALVE, 15 (includes Ref. Nos. 78 & 79) FILTER, DISC SPRING, FILTER SEALING CAP, 50 SCREW, TAPPING SHAFT, BYPASS LEVER, BYPASS PACKING SPRING, 8 RING SEAL RING, 35 HOUSING, UPPER ASSEMBLY, Complete (Includes Ref. Nos. 76 & 77) PIN, ROLL WASHER, SEAL 8 BOLT CASE, CENTER A PIN, 3 x 9.8 FILTER, 40U BOLT, 10 60 CYLINDER BLOCK PUMP SHAFT, TAPERED BEARING RING, E15 HOUSING BEARING, 51106 CYLINDER BLOCK SHAFT, MOTOR E-RING MOTOR GEAR BEARING, 6202UC3 WASHER, 12 x 24 x 1 SWASH PLATE ASSEMBLY BEARING, K81105 THRUST PLATE, A THRUST PLATE, B THRUST METAL SEAL, TC162606 SHAFT ASSEMBLY, CONTROL (Includes ref. Nos. 41, 42, 43, 44, 45, 46 & 47) SHAFT, CONTROL CONTROL ARM, B COLLAR, CONTROL SPRING, TORSION PIN, 6.0A x 25 WASHER, 17 x 30 x 1 RING FULCRUM ECCENTRICITY Footnotes: The above parts group applies to the following Mfg. Nos.: 1693583 1693494 1693686 Baron, 18HP Tractor Baron, 18HP Tractor (Export) Baron, 18HP Tractor (Export) TP 400-2275-02-BR-S 11 Transmission Service Parts - Tuff Torq K51 Transaxle 1720108 NOTE: Unless noted otherwise, use the standard hardware torque specification chart. 61 23 13 12 24 15 25 8 5 62 7 64 52 63 3 97 76 51 4 65 79 23 78 50 53 49 14 77 39 76 41 63 54 48 55 47 10 43 46 38 37 44 11 34 42 45 37 35 40 36 22 74 29 32 28 33 18 72 64 39 70 31 67 75 65 71 68 69 73 62 60 26 66 29 19 21 20 56 57 32 31 30 27 59 54 6 1 16 37 31 58 57 17 37 The above parts group applies to the following Mfg. Nos.: 1693583 1693494 1693686 Baron, 18HP Tractor Baron, 18HP Tractor (Export) Baron, 18HP Tractor (Export) © Copyright 2001 Simplicity Manufacturing, Inc. All Rights Reserved. 12 TP 400-2275-02-BR-S Transmission Service Parts - Tuff Torq K51 Transaxle REF NO. 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 PART NO. QTY. 1707879 1708692 1718100 1718101 1708689 1718102 1718103 1718104 1720439 1720440 1718107 1720441 1718109 1718110 1718111 1718112 1718113 1718114 1718115 1721185 1718119 1720442 1718117 1718121 1718122 1718069 1717749 * * * * 2 1 1 1 1 1 1 1 2 1 1 1 1 2 2 2 2 1 1 1 1 1 1 1 2 2 2 2 1 1 1 DESCRIPTION PACKING NUT, 12 PIN, 6.0A x 4.0 LEVER, CONTROL WASHER GEAR, FINAL GEAR KIT, Differential SHAFT, REDUCTION WASHER, 12 x 32 x 3.2 GEAR, REDUCITON PINION, FINAL AXLE SHAFT, L H AXLE SHAFT, R H BUSHING, 19 x 21 SEAL, 19 x 32 x 8 WASHER, THRUST RING, 17 DISC BRAKE SHOE, BRAKE ARM, BRAKE PLATE, BRAKE KIT, BRAKE CAM (Includes ref. Nos. 39, 71 & 72) SHAFT, BRAKE PACKING, P29 BOLT, 8 x 30 KNOCK PIN, 12 x 22 KEY, Parrallel Pin, 3/16 x 3/16 x 2 BUSHING, 19.02 UPPER HOUSING BODY, Vent Valve CAP, Vent Valve Footnotes: * Not a serviceable part. The above parts group applies to the following Mfg. Nos.: 1693583 1693494 1693686 Baron, 18HP Tractor Baron, 18HP Tractor (Export) Baron, 18HP Tractor (Export) TP 400-2275-02-BR-S 13 Foot Controls Group 985547Foot NOTE: Unless noted otherwise, use the standard hardware torque specification chart. 3 4 5 13 12 18 14 15 16 6 17 7 8 9 10 11 2 1 22 44 20 18 17 21 43 23 19 22 35 34 24 24 36 11 25 1 42 26 41 24 40 39 31 14 Early Models 38 33 37 32 24 23 30 29 28 27 Hook spring to rear fuel hose support guide The above parts group applies to the following Mfg. Nos.: 1693583 1693494 1693686 Baron, 18HP Tractor Baron, 18HP Tractor (Export) Baron, 18HP Tractor (Export) © Copyright 2001 Simplicity Manufacturing, Inc. All Rights Reserved. 14 TP 400-2275-02-BR-S Foot Controls Group REF NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 PART NO. QTY. 1663114 1717765 1718944 1715834 1715835 1720007 1916965 1916950 1960136 920427 1931337 1704629 1720233 1960044 1919438 1704756 1718014 1918447 1720224 1960070 1719271 1919326 1928352 1924940 1667811 174561 1921971 1718016 1704420 1960020 1717769 1721133 1931353 1922755 1922611 1960339 1923362 1917356 1720882 1720724 1709950 1717767 1717186 1720223 2 1 1 1 1 1 2 2 2 2 3 1 1 2 1 1 1 4 1 1 1 4 2 4 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 DESCRIPTION BUSHING, Nylon PEDAL & SHAFT ASSEMBLY, Brake PAD, Foot Pedal, Black Rubber PEDAL, Foot Forward, Balck Rubber PEDAL, Foot Reverse, Black Rubber PEDAL ASSEMBLY, Foot LOCKWASHER, 3/8 NUT, Hex, 3/8-16 CAPSCREW, Hex Head, 3/8-16 x 1 LOCKWASHER, External Tooth, 3/8 CARRIAGE BOLT, 5/16-18 x 1-1/4 SPACER CAM & WELD PIN ASSEMBLY, Lift WASHER, 5/16 NUT, Hex Lock ESNA Light, 5/16-18 LINK, LIFT, Upper LINK, Lift PIN, Cotter, 3/32 X 3/4 ROD, Clutch 2 Bends WASHER, 1 LEVER, Clutch Painted WASHER, 5/16 NUT, Hex Flange Whizlock, 3/8-16 WASHER, 3/8 SPACER PULLEY CAPSCREW, 3/8-16 x 1-3/4 SPRING, Extension RING, Extension Klipring WASHER, 5/8 PIVOT ASSEMBLY, Idler PULLEY, Idler CARRIAGE BOLT, 3/8-16 x 1-3/4 WASHER, 3/8 WASHER, 3/8 NUT, Hex Lock ESNA Light, 3/8-16 NUT, Hex Center Lock, 5/16-18 LOCKWASHER, 5/16 (Early Models) SPACER SPRING, Torsion ACTUATOR, Switch ARM, Foot Pedal CAM, Lift Painted CAM, Parking Brake Footnotes: The above parts group applies to the following Mfg. Nos.: 1693583 1693494 1693686 Baron, 18HP Tractor Baron, 18HP Tractor (Export) Baron, 18HP Tractor (Export) TP 400-2275-02-BR-S 15 Hand Controls Group 985547Hand NOTE: Unless noted otherwise, use the standard hardware torque specification chart. 11 Through hole in upper dash 8 Lower dash hole 1 4 2 14 12 3 15 9 16 5 Grease 6 10 13 7 16 19 18 17 13 See Foot Controls 20 23 22 16 21 The above parts group applies to the following Mfg. Nos.: 1693583 1693494 1693686 Baron, 18HP Tractor Baron, 18HP Tractor (Export) Baron, 18HP Tractor (Export) © Copyright 2001 Simplicity Manufacturing, Inc. All Rights Reserved. 16 TP 400-2275-02-BR-S Hand Controls Group REF NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 PART NO. QTY. 1960223 1924356 1705590 1717989 1919381 1919438 1704623 1718219 176440 1704425 1713855 1720232 1923360 1719989 916168 1715025 1719988 174896 1719990 1960027 158399 1719981 1719940 1 1 1 1 1 1 1 1 1 1 1 1 2 1 1 4 1 1 1 1 1 1 1 DESCRIPTION CARRIAGE BOLT, 5/16-18 x 1-1/4 WASHER, 3/8 SPACER ROD, E-Coat Lift Handle, 13.23 Long WASHER, 5/16 NUT, Hex Lock ESNA Light, 5/16-18 ROD, Link Lift Upper KNOB, Lift Rod, Black BUSHING, Nylon TUBE, Shift, 8.60 Long KNOB, 3 Sided Soft ROD, 15.3 Long Parking Brake PIN, Cotter, 1/16 x 3/4 ROD & LATCH ASSEMBLY, R H PIN, Spring, 1/8 x 3/4 BUSHING LATCH & SPACER ASSEMBLY, L H SPRING, Extension ROD, 22.31 Long Latch, Yellow WASHER, Flat RING-E, Return Extension LEVER & ROD ASSEMBLY, Hopper Open KNOB Footnotes: The above parts group applies to the following Mfg. Nos.: 1693583 1693494 1693686 Baron, 18HP Tractor Baron, 18HP Tractor (Export) Baron, 18HP Tractor (Export) TP 400-2275-02-BR-S 17 Hood, Grille & Dash Group 985546 NOTE: Unless noted otherwise, use the standard hardware torque specification chart. 5 7 4 6 3 2 8 37 38 39 40 1 9 5 5 36 11 10 5 12 20 13 34 16 13 21 19 35 17 18 13 14 15 13 33 32 12 31 16 22 30 29 16 23 28 42 27 26 24 25 41 The above parts group applies to the following Mfg. Nos.: 1693583 1693494 1693686 Baron, 18HP Tractor Baron, 18HP Tractor (Export) Baron, 18HP Tractor (Export) © Copyright 2001 Simplicity Manufacturing, Inc. All Rights Reserved. 18 TP 400-2275-02-BR-S Hood, Grille & Dash Group REF NO. 1 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 22 23 24 25 26 27 28 29 30 31 32 33 34 34 35 36 37 38 39 40 41 42 PART NO. QTY. 1703240 41703240 1717519 1720329 1719739 1960368 1720327 1709188 1720326 1720328 176440 1927428 1925003 1960295 1722006 1704927 1920397 1719978 1719845 1921319 1670675 1709238 1704879 41704879 1933896 1960096 171600 1721203 1716128 1705249 1705248 1960373 1704626 1704628 1930601 1704878 41704878 1703945 1703248 1677371 1703249 1703946 1677370 1721146 1930594 1 1 1 1 1 10 1 1 1 1 1 1 7 22 1 2 10 1 1 2 2 1 1 1 2 2 2 1 2 2 2 2 2 2 2 1 1 1 1 1 1 1 1 1 2 DESCRIPTION HOOD, Orange HOOD, Red EDGING, 9” Long, Black Rubber SEAL, Foam, 1 x 1-1/4 Horseshoe DUCT, Air 16GA NUT, Speed Lug LENS, Indicator R H , (PTO On) PLUG, Hole, Black Plastic DASHBOARD, Lenses, (Includes Ref. Nos. 6 & 9) LENS, Indicator L H, (BLUE/GREEN) BUSHING, Nylon CAPSCREW, Hex Washer Head, Taptite, 1/4-20 x 3/8 CAPSCREW, Hex Washer Head, Taptite, 1/4-20 x 1/2 CAPSCREW, Hex Flange Whizlock, 1/4-20 x 5/8 BULKHEAD GROMMET NUT, Hex Lock ESNA Light 1/4-20 SUPPORT, Bulkhead R H w/Hole SUPPORT, Bulkhead L H WASHER, 1/4 BUMPER, Button, Black Rubber DASH, Lower 16GA PANEL & WELD STUD ASSEMBLY, L H Side, Orange PANEL & WELD STUD ASSEMBLY, L H Side, Red NUT, Hex Lock, 10-24 w/Nylon Insert WASHER, 3/16 STRAP, Hood, Black Rubber 4.8” Long GRILLE, 16GA HINGE, Hood SPACER PIVOT, Hood CAPSCREW, Hex Washer Head, Taptite, 5/16-18 x 1 SPACER, Nylon PIN, Quick, (Hairpin) CAPSCREW, Hex Wasker Head, Taptite, 5/16-18 x 5/8 PANEL & WELD STUD ASSEMBLY, R.H. Side, Orange PANEL & WELD STUD ASSEMBLY, R.H. Side, Red HEADLIGHT ASSEMBLY, (Includes Ref. Nos. 36, 37, 38, 39, & 40) LENS, Headlight BULB, Headlight BEZEL, Headlight HEAT SHEILD, Headlight SOCKET, Headlight BUMPER CAPSCREW, Hex Flange Whizlock, 1/4-20 x 3/4 Footnotes: The above parts group applies to the following Mfg. Nos.: 1693583 1693494 1693686 Baron, 18HP Tractor Baron, 18HP Tractor (Export) Baron, 18HP Tractor (Export) TP 400-2275-02-BR-S 19 Seat, Seat Deck & Fuel Tank Group 985548 NOTE: Unless noted otherwise, use the standard hardware torque specification chart. 2 1 3 39 4 38 36 37 5 13 6 35 14 7 15 33 34 11 9 12 16 20 8 10 17 40 19 18 23 28 24 27 21 22 26 25 32 31 30 29 The above parts group applies to the following Mfg. Nos.: 1693583 1693494 1693686 Baron, 18HP Tractor Baron, 18HP Tractor (Export) Baron, 18HP Tractor (Export) © Copyright 2001 Simplicity Manufacturing, Inc. All Rights Reserved. 20 TP 400-2275-02-BR-S Seat, Seat Deck & Fuel Tank Group REF NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 29 30 31 32 33 34 35 36 37 38 39 40 PART NO. QTY. 1721702 1709307 1931339 172434 1924940 1919439 1663752 1718858 1931350 1928352 1931648 1720447 1704299 1709308 1719809 1707137 1709256 1919438 1704724 1721111 1715917 1719206 1654930 1704108 1916622 1916964 1921319 1707471 1719679 41719679 1960459 1708361 1925003 1701229 1930601 1719392 1704728 1714441 1704723 1719712 1931339 1 1 2 1 2 2 2 1 2 2 4 2 2 2 1 1 2 2 2 1 1 1 1 1 2 2 2 1 1 1 2 1 4 1 2 1 2 1 1 1 2 DESCRIPTION SEAT, w/Cusion No Arms SUPPORT, Seat Pivot CARRIAGE BOLT, 5/16-18 x 2 CLIP, Speed Wire WASHER, 3/8 NUT, Hex Lock ESNA Light, 3/8-16 SPACER BRACKET CARRIAGE BOLT, 3/8-16 x 2 NUT, Hex Flange Whizlock, 3/8-16 CAPSCREW, Hex Flange Whizlock, 5/16-18 x 1/2 EDGING, 11 Long, Black Rubber SPACER SPRING, Compression PLATE, Switch SPRING, Extension, Black WASHER, Spring, Cone NUT, Hex Lock ESNA Light, 5/16-18 COVER, Spring, Black Vinyl DOOR & HINGE ASSEMBLY, Hopper CAP, Fuel Tank, Black TANK, Fuel BUSHING, Rubber ELBOW & TUBE ASSEMBLY NUT, Hex 1/4-20 LOCKWASHER, 1/4 WASHER, 1/4 SPRING, Extension DECK & WELD STUDS ASSEMBLY, Seat, Orange DECK & WELD STUDS ASSEMBLY, Seat, Red CAPSCREW, Truss Head, Torx Drive, 3/8-16 x 1 PLATE CAPSCREW, Hex Washer Head, Taptite, 1/4-20 x 1/2 BUSHING, Snap CAPSCREW, Hex Washer Head, Taptite, 5/16-18 x 5/8 HOLDER, Cup, Black Plastic SPRING, Compression SLIDE, Seat GRIP, Black Vinyl LEVER, Seat Release CARRIAGE BOLT, 1/4-20 x 3/4 Footnotes: The above parts group applies to the following Mfg. Nos.: 1693583 1693494 1693686 Baron, 18HP Tractor Baron, 18HP Tractor (Export) Baron, 18HP Tractor (Export) TP 400-2275-02-BR-S 21 Hopper Group 985551 NOTE: Unless noted otherwise, use the standard hardware torque specification chart. 2 3 1 4 5 7 4 9 8 6 Apply adheasive to secure edge 19 10 12 11 8 8 18 4 4 8 4 12 8 4 13 10 12 12 17 13 14 4 15 12 8 12 16 8 4 The above parts group applies to the following Mfg. Nos.: 1693583 1693494 1693686 Baron, 18HP Tractor Baron, 18HP Tractor (Export) Baron, 18HP Tractor (Export) © Copyright 2001 Simplicity Manufacturing, Inc. All Rights Reserved. 22 TP 400-2275-02-BR-S Hopper Group REF NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 PART NO. QTY. 1720020 1719939 1920283 1917356 1921332 1708007 1919381 1917372 1721983 1720013 1720010 1931335 1720083 1719351 1720458 1720008 1720011 1720009 1721175 1 1 2 20 2 6 6 18 1 2 1 12 2 2 2 1 1 1 1 DESCRIPTION LID ASSEMBLY, Hopper HANDLE, Grab WASHER, 5/16 LOCKWASHER, 5/16 CAPSCREW, Hex Head, 5/16-18 x 3/4 CLAMP WASHER, 5/16 NUT, Hex 5/16-18 BAG, Grass Plastic Bottom, Black ROD ROD & TABS ASSEMBLY, Bottom Bag CARRIAGE BOLT, 5/16-18 x 1 BRACE & PIVOT ASSEMBLY, Cylinder CYLINDER, 8.0” Stoke NUT, Push On SUPPORT, Bag Bottom ROD & BRACES ASSEMBLY, Bag Front ROD & TABS ASSEMBLY, Top Bag EDGING, Seal Footnotes: The above parts group applies to the following Mfg. Nos.: 1693583 1693494 1693686 Baron, 18HP Tractor Baron, 18HP Tractor (Export) Baron, 18HP Tractor (Export) TP 400-2275-02-BR-S 23 Electrical Group – Lower Harness 985549Lower NOTE: Unless noted otherwise, use the standard hardware torque specification chart. 8 10 9 7 3 4 11 12 13 6 14 5 4 15 2 1 16 21 17 18 20 19 22 The above parts group applies to the following Mfg. Nos.: 1693583 1693494 1693686 Baron, 18HP Tractor Baron, 18HP Tractor (Export) Baron, 18HP Tractor (Export) © Copyright 2001 Simplicity Manufacturing, Inc. All Rights Reserved. 24 TP 400-2275-02-BR-S Electrical Group – Lower Harness REF NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 PART NO. QTY. 1674358 932747 1719681 925094 1719999 1701229 1714770 1720401 1921319 1925003 1720119 1720120 1704379 1720118 1720001 122023 916622 1668819 1713163 1707232 920427 930598 1 1 1 2 1 1 1 1 2 6 1 1 1 1 1 1 1 1 1 1 1 1 DESCRIPTION HARNESS, Wiring For Headlights TIE, Self Locking, 3-5/8” Long SWITCH, Push Button Foot Pedal TIE, Self Locking, 7-5/16” Long HARNESS, Wiring BUSHING, Snap SWITCH, Push Button Seat Switch SWITCH, Push Button Gray w/Boot, Safety WASHER, Flat, 1/4 CAPSCREW, Hex Washer Head, Taptite,1/4-20 x 1/2 PLATE, Cover Hopper Switch ROD & WASHER ASSEMBLY, Hopper Switch SWITCH, Push Button, Snap In, Grass Catcher Alarm BRACKET, Hopper Switch WIRE ASSEMBLY, Rear Bagger BOOT, Insulator, Battery Terminal NUT, Hex 1/4-20 CABLE, # 6 x 25 Long, (2) Ring Terminals CABLE, # 6 x 26 Long, 1/4 & 3/8 Ring Terms WIRE ASSEMBLY LOCKWASHER, External Tooth, 3/8 CAPSCREW, Hex Washer Head, Taptite, 3/8-16 x 1 1/2 Footnotes: The above parts group applies to the following Mfg. Nos.: 1693583 1693494 1693686 Baron, 18HP Tractor Baron, 18HP Tractor (Export) Baron, 18HP Tractor (Export) TP 400-2275-02-BR-S 25 Electrical Group – Upper Harness 985549Upper NOTE: Unless noted otherwise, use the standard hardware torque specification chart. 6 33 9 8 34 10 5 4 Note: Apply non-conductive grease to ignition switch terminals and wire harness plug before connecting. 12 3 5 7 11 13 2 Hour meter leads for accessory kit 4 Purple wire to positive (+) side 1 15 14 15 32 31 30 18 19 16 20 17 22 18 19 20 21 Note: Replacement battery has no vent caps or drain tube 25 29 23 18 25 26 28 24 27 The above parts group applies to the following Mfg. Nos.: 1693583 1693494 1693686 Baron, 18HP Tractor Baron, 18HP Tractor (Export) Baron, 18HP Tractor (Export) © Copyright 2001 Simplicity Manufacturing, Inc. All Rights Reserved. 26 TP 400-2275-02-BR-S Electrical Group – Upper Harness REF NO. PART NO. QTY. 1 2 3 1720117 1719999 1686734 1 1 1 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 1960536 1676130 1716332 1960547 1717549 1717550 1703799 1685290 1665238 1665237 1668819 920426 1920263 1603618 921319 916964 1916622 1677296 920594 1704632 1718596 923341 1685215 1704349 1704112 1612103 1713163 1960369 1704614 101025 1717163 2 2 1 1 1 1 1 1 1 1 1 2 2 1 4 2 2 1 2 2 1 2 1 2 1 1 1 4 1 1 1 DESCRIPTION BUZZER, Pulse, (Grass Bag Full) HARNESS, Wiring SWITCH ASSEMBLY, Ignition 5/8-32 6 Terminal (Includes Ref. Nos. 7, 8, 9, 33 & 34) CAPSCREW, Hex Washer Head, 1/4 x 1/2 LAMP, Indicator SWITCH, PTO Push/Pull w/Symbols LOCKWASHER, Internal Tooth, 5/8 NUT, Hex Flange 5/8-32 COVER, Ignition Switch SWITCH, Rocker, Headlight SOLENOID, 4 Pole 12 Volt DC BREAKER, Circuit 12 Volt 20 amps w/Tab WIRE, 12GA, Red CABLE, # 6 x 25 Long (2) Ring Terminals LOCKWASHER, External Tooth, 5/16 NUT, Hex, 5/16-24 NF CABLE, # 6 x 8 Long, (2) Ring Terminals WASHER, 1/4 LOCKWASHER, 1/4 NUT, Hex, 1/4-20 BOOT, Insulator, Battery Terminal TIE, Self Locking, 7-5/16” Long ROD, Battery Hold Down BRACKET, Battery Hold Down CAPSCREW, Hex Head, 1/4-20 x 3/4 BATTERY, 12 Volt 6 Cell 340 amps NUT, Plastic Expanding TRAY, Battery HOSE, Drain CABLE, # 6 x 26 Long 1/4 & 3/8 Ring Terminals CAPSCREW, Hex Washer Head, 3/8-16 x 1/2 STRAP WASHER, 5/8 KEY, Ignition (Set of 2) Footnotes: The above parts group applies to the following Mfg. Nos.: 1693583 1693494 1693686 Baron, 18HP Tractor Baron, 18HP Tractor (Export) Baron, 18HP Tractor (Export) TP 400-2275-02-BR-S 27 Wheel & Tires Group WheelsMISC NOTE: Unless noted otherwise, use the standard hardware torque specification chart. 1 3 2 8 9 10 4 5 6 11 7 4 Front Wheels 12 13 15 13 22 17 14 18 16 13 Rear Wheels 19 20 21 The above parts group applies to the following Mfg. Nos.: 1693583 1693494 1693686 Baron, 18HP Tractor Baron, 18HP Tractor (Export) Baron, 18HP Tractor (Export) © Copyright 2001 Simplicity Manufacturing, Inc. All Rights Reserved. 28 TP 400-2275-02-BR-S Wheel & Tires Group REF NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 PART NO. QTY. 1960160 1713166 1664090 1713167 172353 912808 1715032 1701435 1611710 1676519 1709856 1717749 960202 1717451 1713170 173477 1716132 172353 1701435 927794 1676519 1720099 2 2 2 4 2 2 2 4 2 2 2 2 8 2 2 2 2 2 2 2 2 2 DESCRIPTION WASHER, Special, 3/4 (Install to the inside of wheel) TIRE, 15 x 6.00-6 TUBE, 4.10/3.50-6 BEARING VALVE STEM & CAP FITTING, Grease WHEEL ASSEMBLY, (Includes Ref. No. 4) RETAINER, Hub Cap, Black RING, Retaining CAP, Hub WHEEL & TIRE ASSEMBLY, 15 x 6.00-6 (Includes Ref. Nos. 2, 4, 5, 6, & 7) KEY WASHER SPACER TIRE, 18 x 8 1/2-8 TUBE WHEEL ASSEMBLY VALVE STEM & CAP RETAINER, Cap, Hub E-RING CAP, Hub, Black WHEEL & TIRE ASSEMBLY, (Includes Ref. Nos. 15, 17, & 18) Footnotes: The above parts group applies to the following Mfg. Nos.: 1693583 1693494 1693686 Baron, 18HP Tractor Baron, 18HP Tractor (Export) Baron, 18HP Tractor (Export) TP 400-2275-02-BR-S 29 Decals Group DecalsMISC NOTE: Unless noted otherwise, use the standard hardware torque specification chart. 6 10 9 7 8 3 7 4 2 4 12 13 11 4 STOP ENGINE. PUSH DRIVE MOTOR STOPPEN. MOTOR ANHALTEN. STOP MOTOR. ARRETER LE MOTEUR. FERMARE MOTORE. DUWEN SCHIEBEN SKUB POUSSER SPINGERE RIJDEN FAHREN KØR CONDUIRE GUIDARE 14 15 1722384 DO NOT TOW! NIET SLEPEN! NICHT SCHLEPPEN! IKKE BUGSERE! NE PAS REMORQUER! NON TRAINARE! 14 1 5 5 6 5 The above parts group applies to the following Mfg. Nos.: 1693583 1693554 1693560 1693585 Baron, 18HP Tractor 40" Mower Deck 40" Mower Deck 40" Mower Deck © Copyright 2001 Simplicity Manufacturing, Inc. All Rights Reserved. 30 TP 400-2275-02-BR-S Decals Group REF NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 PART NO. QTY. 1721197 1708927 1717706 1718508 1720660 1720661 1720658 1720412 1720454 1720460 1720504 1720505 1717692 1722384 1721141 1 1 1 3 2 1 1 1 1 1 1 1 1 1 1 DESCRIPTION DECAL, Cutting Height DECAL, Logo, USA DECAL, Engine, 18V-Twin DECAL, Simplicity w/Logo, Fuel Resistant DECAL, Danger, Rotating Blades DECAL, Danger, Catcher Open DECAL, Operating Instructions DECAL, Baron DECAL, Touch Up Paint DECAL, Drive Belts/Mower Blades DECAL, Hood Stripe L H DECAL, Hood Stripe R H DECAL, Simplicity Logo DECAL, Transmission Release Valve DECAL, Draw Bar Footnotes: The above parts group applies to the following Mfg. Nos.: 1693583 1693554 1693560 1693585 Baron, 18HP Tractor 40" Mower Deck 40" Mower Deck 40" Mower Deck TP 400-2275-02-BR-S 31 Decals Group (Export) DecalsExportMISC NOTE: Unless noted otherwise, use the standard hardware torque specification chart. 7 6 15 11 10 8 10 Max. 10 Max. 1720392 20 9 PUSH DRIVE MOTOR STOPPEN. MOTOR ANHALTEN. STOP MOTOR. ARRETER LE MOTEUR. FERMARE MOTORE. DUWEN SCHIEBEN SKUB POUSSER SPINGERE RIJDEN FAHREN KØR CONDUIRE GUIDARE DO NOT TOW! NIET SLEPEN! NICHT SCHLEPPEN! IKKE BUGSERE! NE PAS REMORQUER! NON TRAINARE! 2 1722384 8 3 STOP ENGINE. 20, 21 16 4 14 13,12 Locate next to Serial Plate 4 18 1 19 17 5 5 18 7 6 5 1720390 The above parts group applies to the following Mfg. Nos.: 1693494 1693686 1693575 Baron, 18HP Tractor (Export) Baron, 18HP Tractor (Export) 102 cm Mower Deck (Export) © Copyright 2001 Simplicity Manufacturing, Inc. All Rights Reserved. 32 TP 400-2275-02-BR-S Decals Group (Export) REF NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 PART NO. QTY. 1721197 1708927 1717706 1718508 1720389 1720390 1720391 1720392 1720412 1720454 1720460 1720504 1720505 1717692 1721108 * 1721141 1721107 1722384 1722475 1722474 1 1 1 3 2 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 DESCRIPTION DECAL, Cutting Height DECAL, Logo, USA DECAL, Engine, 18V-Twin DECAL, Simplicity w/Logo, Fuel Resistant DECAL, Danger, Rotating Blades DECAL, Danger, Catcher Open DECAL, Danger Operating w/o Catcher DECAL, Operating Instructions Symbols DECAL, Baron DECAL, Touch Up Paint DECAL, Drive Belts/Mower Blades DECAL, Hood Stripe L H DECAL, Hood Stripe R H DECAL, Simplicity Logo DECAL, Danger Hopper Lid DECAL, GS-Safety DECAL, Drawbar DECAL, Danger, Discharge Tube DECAL, Transmission Release Valve DECAL, Massey Ferguson Hood L H DECAL, Massey Ferguson Hood R H Footnotes: * Not a serviceable part. The above parts group applies to the following Mfg. Nos.: 1693494 1693686 1693575 Baron, 18HP Tractor (Export) Baron, 18HP Tractor (Export) 102 cm Mower Deck (Export) TP 400-2275-02-BR-S 33 40" (102 cm) Mower Deck – Housing Arbors & Blades (Serial No. 0001 - 1999) 985742 NOTE: Unless noted otherwise, use the standard hardware torque specification chart. Torque screws to 50-70 ft. lbs. 10 Torque screws to 50-70 ft. lbs. 1 3 2 11 3 12 4 4 5 5 6 6 7 7 8 8 9 9 32 31 30 29 13 27 28 26 14 25 24 15 22 16 17 14 18 19 20 21 3 15 16 17 3 20 19 23 21 The above parts group applies to the following Mfg. Nos.: 1693554 1693560 1693585 1693575 40" Mower Deck 40" Mower Deck 40" Mower Deck 102 cm Mower Deck (Export) © Copyright 2001 Simplicity Manufacturing, Inc. All Rights Reserved. 34 TP 400-2275-02-BR-SMA 40" (102 cm) Mower Deck – Housing Arbors & Blades (Serial No. 0001 - 1999) REF NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 25 26 27 28 29 30 31 32 PART NO. QTY. 1936723 1933263 1656916 1719766 1657969 1655729 1707335 1676278 1703273 1930585 1713091 1719862 1721153 1700230 1700229 1655777 1657528 1719737 1719985 1720587 923471 1664847 1722258 1719736 1686784 41686784 1721154 1924856 1960404 1933896 1960096 171600 1686817 1 1 4 2 2 2 2 2 2 1 1 1 1 2 2 2 2 1 2 2 2 12 2 1 1 1 1 6 1 1 3 1 1 DESCRIPTION CAPSCREW, Hex Head, 7/16-14 x 1-3/4 G8 WASHER, 7/16 WASHER, Spring, 1-3/4 SPROCKET & FLANGE ASSEMBLY, Rivited SHIELD, Bearing, Mower Arbor Upper HOUSING, Arbor Top GASKET, Foam ARBOR SHAFT & BEARINGS ASSEMBLY HOUSING, Arbor Bottom w/Lube Fitting CAPSCREW, Hex Head, 7/16-14 x 3-1/2 G8 PULLEY HUB COVER, Arbor R H WASHER, Shim SHIELD, Bearing, Mower Arbor Lower ADAPTER, Blade 26, 30, 36, 42 & 48” RING BLADE, Mower RH 40 WASHER, 1 WASHER, Spline CAPSCREW, Hex Head, 7/16-14 x 1-1/4 G8 CAPSCREW, Hex Washer Head, Taptite, 5/16-18 x 3/4 PIN, Blade BLADE, Mower LH 40 HOUSING ASSEMBLY, 40” Mower, 2 Spindle, Orange HOUSING ASSEMBLY, 40” Mower, 2 Spindle, Red COVER, Arbor LH CAPSCREW, Hex Washer Head, Taptite, 5/16-18 x 1/2 CAPSCREW, Truss Head, Phillips, #10-24 x 3/4 NUT, Hex Nylock , 10-24 WASHER, 3/16 STRAP, Hood, Black Rubber, 4.8” Long TUBE ASSEMBLY, Top & Bottom Rear Footnotes: The above parts group applies to the following Mfg. Nos.: 1693554 1693560 1693585 1693575 40" Mower Deck 40" Mower Deck 40" Mower Deck 102 cm Mower Deck (Export) TP 400-2275-02-BR-SMA 35 40" (102 cm) Mower Deck – Housing Arbors & Blades (Serial No. 2000 - 2999) NOTE: Unless noted otherwise, use the standard hardware torque specification chart. Torque screws to 50-70 ft. lbs. 10 Torque screws to 50-70 ft. lbs. 1 3 2 11 3 12 4 4 5 5 6 6 7 7 8 8 9 9 32 31 30 29 13 27 28 19 26 17 14 25 24 15 22 16 18 33 20 21 3 14 15 20 23 3 16 21 The above parts group applies to the following Mfg. Nos.: 1693554 1693560 1693585 1693575 40" Mower Deck 40" Mower Deck 40" Mower Deck 102 cm Mower Deck (Export) © Copyright 2001 Simplicity Manufacturing, Inc. All Rights Reserved. 36 TP 400-2275-02-BR-SMA 40" (102 cm) Mower Deck – Housing Arbors & Blades (Serial No. 2000 - 2999) REF NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 25 26 27 28 29 30 31 32 33 PART NO. QTY. 1936723 1933263 1656916 1719766 1657969 1655729 1707335 1676278 1703273 1930585 1713091 1719862 1721153 1700230 1700229 1655777 1675044 1719737 1721258 1722257 923471 1960373 1722258 1719736 1686784 41686784 1721254 1924856 1960404 1933896 1960096 171600 1686817 1677247 1 1 4 2 2 2 2 2 2 1 1 1 1 2 2 2 4 1 1 2 2 12 2 1 1 1 1 6 1 1 3 1 1 2 DESCRIPTION CAPSCREW, Hex Head, 7/16-14 x 1-3/4 G8 WASHER, 7/16 WASHER, Spring, 1-3/4 SPROCKET & FLANGE ASSEMBLY, Rivited SHIELD, Bearing, Mower Arbor Upper HOUSING, Arbor Top GASKET, Foam ARBOR SHAFT & BEARINGS ASSEMBLY HOUSING, Arbor Bottom w/Lube Fitting CAPSCREW, Hex Head, 7/16-14 x 3-1/2 G8 PULLEY HUB COVER, Arbor RH WASHER, Shim SHIELD, Bearing, Mower Arbor Lower ADAPTER, Blade 26, 30, 36, 42 & 48” RIVET, Pop BLADE, Mower RH 40 GUARD ASSEMBLY WASHER, Spline CAPSCREW, Hex Head, 7/16-14 x 1-1/4 G8 CAPSCREW, Hex Washer Head, Taptite, 5/16-18 x 1 PIN, Blade BLADE, Mower LH HOUSING ASSEMBLY, 40” Mower, 2 Spindle, Orange HOUSING ASSEMBLY, 40” Mower, 2 Spindle, Red COVER, Arbor LH CAPSCREW, Hex Washer Head, Taptite, 5/16-18 x 1/2 CAPSCREW, Truss Head, Phillips, #10-24 x 3/4 NUT, Hex Nylock , 10-24 WASHER, 3/16 STRAP, Hood, Black Rubber, 4.8” Long TUBE ASSEMBLY, Top & Bottom Rear ARBOR ADAPTER Footnotes: The above parts group applies to the following Mfg. Nos.: 1693554 1693560 1693585 1693575 40" Mower Deck 40" Mower Deck 40" Mower Deck 102 cm Mower Deck (Export) TP 400-2275-02-BR-SMA 37 40" (102 cm) Mower Deck – Housing Arbors & Blades (Serial No. 3000 - and above) NOTE: Unless noted otherwise, use the standard hardware torque specification chart. Torque screws to 50-70 ft. lbs. 10 Torque screws to 50-70 ft. lbs. 1 3 2 11 3 12 4 4 5 5 6 6 7 7 8 8 9 9 32 31 30 29 13 27 28 19 26 17 14 25 24 15 22 16 18 33 20 21 3 14 15 20 23 3 16 21 The above parts group applies to the following Mfg. Nos.: 1693554 1693560 1693585 1693575 40" Mower Deck 40" Mower Deck 40" Mower Deck 102 cm Mower Deck (Export) © Copyright 2001 Simplicity Manufacturing, Inc. All Rights Reserved. 38 TP 400-2275-02-BR-SMA 40" (102 cm) Mower Deck – Housing Arbors & Blades (Serial No. 3000 - and above) REF NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 25 26 27 28 29 30 31 32 33 PART NO. QTY. 1930584 1933263 1656916 1719766 1657969 1655729 1707335 1722396 1703273 960644 1713091 1719862 1721153 1700230 1700229 1655777 1675044 1719737 1721258 1722257 927120 1960373 1722258 1719736 1686784 41686784 1721254 1924856 1960404 1933896 1960096 171600 1686817 1677247 1 1 4 2 2 2 2 2 2 1 1 1 1 2 2 2 4 1 1 2 2 12 2 1 1 1 1 6 1 1 3 1 1 2 DESCRIPTION CAPSCREW, Hex Head, 7/16-14 x 2-3/4 G8 WASHER, 7/16 WASHER, Spring, 1-3/4 SPROCKET & FLANGE ASSEMBLY, Rivited SHIELD, Bearing, Mower Arbor Upper HOUSING, Arbor Top GASKET, Foam ARBOR SHAFT & BEARINGS ASSEMBLY HOUSING, Arbor Bottom w/Lube Fitting CAPSCREW, Hex Head, 7/16-14 x 4-1/2 G8 PULLEY HUB COVER, Arbor RH WASHER, Shim SHIELD, Bearing, Mower Arbor Lower ADAPTER, Blade 26, 30, 36, 42 & 48 RIVET, Pop BLADE, Mower RH GUARD ASSEMBLY WASHER, Spline CAPSCREW, Hex Head, 7/16-14 x 2-1/4 G8 CAPSCREW, Hex Washer Head, Taptite, 5/16-18 x 1 PIN, Blade BLADE, Mower LH HOUSING ASSEMBLY, 40” Mower, 2 Spindle, Orange HOUSING ASSEMBLY, 40” Mower, 2 Spindle, Red COVER, Arbor LH CAPSCREW, Hex Washer Head, Taptite, 5/16-18 x 1/2 CAPSCREW, Truss Head, Phillips, #10-24 x 3/4 NUT, Hex Nylock, 10-24 WASHER, 3/16 STRAP, Hood, Black Rubber, 4.8” Long TUBE ASSEMBLY, Top & Bottom Rear ARBOR ADAPTOR Footnotes: The above parts group applies to the following Mfg. Nos.: 1693554 1693560 1693585 1693575 40" Mower Deck 40" Mower Deck 40" Mower Deck 102 cm Mower Deck (Export) TP 400-2275-02-BR-SMA 39 40" (102 cm) Mower Deck – Belt, Clutch & Support (Serial No. 0001 - 1999) 985541 NOTE: Unless noted otherwise, use the standard hardware torque specification chart. 3 2 4 1 31 5 6 30 7 15 5 8 9 10 29 14 28 16 10 10 27 11 15 16 26 13 12 10 25 24 32 5 23 19 18 17 20 22 21 The above parts group applies to the following Mfg. Nos.: 1693554 1693560 1693585 1693575 40" Mower Deck 40" Mower Deck 40" Mower Deck 102 cm Mower Deck (Export) © Copyright 2001 Simplicity Manufacturing, Inc. All Rights Reserved. 40 TP 400-2275-02-BR-SMA 40" (102 cm) Mower Deck – Belt, Clutch & Support (Serial No. 0001 - 1999) REF NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 PART NO. QTY. 1721533 101096 1919439 1719842 1924940 157081 1719965 1720444 1928957 1922755 1960615 1657242 1715435 1921971 1719562 1719221 1928352 1921969 172329 1713578 156302 1715759 1720044 1960519 1721425 1674671 1719923 1666697 1930601 1923701 1721117 1922694 1 1 2 1 5 2 1 1 1 6 1 1 1 1 2 2 1 2 2 1 1 1 1 1 1 1 1 1 1 1 1 2 DESCRIPTION V-BELT, Mower Drive, PTO PULLEY NUT, Hex Lock ESNA Light, 3/8-16 STOP, Belt WASHER, 3/8 SPACER GRIP, Black Vinyl ARM ASSEMBLY, Idler w/Bushings & Lube CAPSCREW, Hex Head, 3/8-16 x 2-3/4 G8 WASHER, 3/8 CARRIAGE BOLT, 3/8-16 x 2-1/2 SPACER SPRING, Extension CAPSCREW, Hex Head, 3/8-16 x 1-3/4 PULLEY, Idler 22 Teeth HUB NUT, Hex Flange Whizlock, 3/8-16 CAPSCREW, Hex Head, 3/8-16 x 1-1/2 SPACER ROD, Mower Hitch SPRING, Extension ROD HITCH, Mower NUT, Push On WASHER & LOCK NUT ASSEMBLY, 3/8-16 SPRING, Extension ARM, Idler SPACER CAPSCREW, Hex Washer Head, Taptite, 5/16-18 x 1/2 CAPSCREW, Hex Head, 3/8-16 x 2 BELT, Timing, Arbor Drive NUT, Hex Lock ESNA Heavy, 3/8-16 Footnotes: The above parts group applies to the following Mfg. Nos.: 1693554 1693560 1693585 1693575 40" Mower Deck 40" Mower Deck 40" Mower Deck 102 cm Mower Deck (Export) TP 400-2275-02-BR-SMA 41 40" (102 cm) Mower Deck – Belt, Clutch & Support (Serial No. 2000 - and above) NOTE: Unless noted otherwise, use the standard hardware torque specification chart. 3 2 1 31 5 4 6 30 7 15 5 8 9 10 29 14 28 16 10 10 27 33 11 15 16 26 13 12 10 25 24 Early 32 Models 5 34 23 19 18 17 20 22 21 The above parts group applies to the following Mfg. Nos.: 1693554 1693560 1693585 1693575 40" Mower Deck 40" Mower Deck 40" Mower Deck 102 cm Mower Deck (Export) © Copyright 2001 Simplicity Manufacturing, Inc. All Rights Reserved. 42 TP 400-2275-02-BR-SMA 40" (102 cm) Mower Deck – Belt, Clutch & Support (Serial No. 2000 - and above) REF NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 PART NO. QTY. 1721533 101096 1919439 1722175 1924940 157081 1719965 1720444 1960614 1922755 1960615 1657242 1715435 1921971 1719562 1719221 1928352 1921969 172329 1713578 156302 1715759 1720044 1960519 1721425 1674671 1719923 1666697 1930601 1923701 1721117 1922694 1933263 960641 1 1 2 1 4 2 1 1 1 6 1 1 1 1 2 2 1 2 2 1 1 1 1 1 1 1 1 1 1 1 1 2 1 2 DESCRIPTION V-BELT, Mower Drive, PTO PULLEY NUT, Hex Lock ESNA Light, 3/8-16 STOP, Belt WASHER, 3/8 SPACER GRIP, Black Vinyl ARM ASSEMBLY, Idler w/Bushings & Lube CAPSCREW, Hex Head, 3/8-16 x 2-3/4 G8 WASHER, 3/8 CARRIAGE BOLT, 3/8-16 x 2-1/2 SPACER SPRING, Extension CAPSCREW, Hex Head, 3/8-16 x 1-3/4 PULLEY, Idler 22 Teeth HUB NUT, Hex Flange Whizlock, 3/8-16 CAPSCREW, Hex Head, 3/8-16 x 1-1/2 SPACER ROD, Mower Hitch SPRING, Extension ROD HITCH, Mower NUT, Push On WASHER & LOCK NUT ASSEMBLY, 3/8-16 SPRING, Extension ARM, Idler SPACER CAPSCREW, Hex Washer Head, Taptite, 5/16-18 x 1/2 CAPSCREW, Hex Head, 3/8-16 x 2 BELT, Timing, Arbor Drive NUT, Hex Lock ESNA Heavy, 3/8-16 WASHER NUT, Hex Lock Alum Insert, 3/8-16 (SN 2000 and above) Footnotes: The above parts group applies to the following Mfg. Nos.: 1693554 1693560 1693585 1693575 40" Mower Deck 40" Mower Deck 40" Mower Deck 102 cm Mower Deck (Export) TP 400-2275-02-BR-SMA 43 40" (102 cm) Mower Deck – Height Adjustment & Rollers - (Early Models) 985540SN1-100 NOTE: Unless noted otherwise, use the standard hardware torque specification chart. 19 5 20 1 21 11 2 22 3 21 12 10 13 14 4 15 16 9 18 8 17 7 23 6 21 24 25 25 47 26 15 27 30 33 28 32 31 32 29 46 34 35 16 33 11 36 37 38 38 45 37 39 40 41 42 22 44 21 43 The above parts group applies to the following Mfg. Nos.: 1693585 1693575 40" Mower Deck, S/N Range 1 to 186 102 cm Mower Deck (Export), S/N Range 1 to 374 © Copyright 2001 Simplicity Manufacturing, Inc. All Rights Reserved. 44 TP 400-2275-02-BR-SMA 40" (102 cm) Mower Deck – Height Adjustment & Rollers - (Early Models) REF NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 PART NO. QTY. 1960093 1714084 1719901 916001 1704087 1706645 118053 1960074 1926149 1704083 1930644 1704116 1917356 1917372 1918448 1924940 1705049 176012 1719543 1923500 1924366 1717675 1931352 1719180 1915726 1719261 1960170 1704086 1704097 1719208 1919326 1960373 1665374 1664847 1719929 1704082 1916965 1916950 1704073 1677507 1924361 172622 1960520 1922694 1706644 1704077 1922606 1 1 1 1 1 1 1 1 2 1 2 1 2 2 1 5 1 1 1 1 14 6 1 1 2 1 1 1 1 1 1 4 4 6 2 1 2 2 1 1 1 1 1 1 1 1 1 DESCRIPTION PAL NUT KNOB, Spinner CRANK, Height Adjust PIN, Spring TRUNNION, Rod TRUNNION, Bracket PIN, Round Head, Drilled, 3/8 x 2 CLIP, Hair Pin CAPSCREW, Hex Head, 5/16-18 x 1 G8 ARM, Rear Adjustable NUT, Hex FlangeTwo-Way Lock, 1/2-13 BRACKET, Height of Cut LOCKWASHER, 5/16 NUT, Hex, 5/16-18 PIN, Cotter WASHER, 3/8 LINK & WELD PINS ASSEMBLY, Lower Lift RETAINER, Pin, Spring SHAFT & BAR ASSEMBLY, Roller PIN, Cotter WASHER, 5/8 ROLLER CARRIAGE BOLT, 3/8-16 x 1-1/2 SHAFT & ARMS ASSEMBLY, 40” Rear NUT, Hex, 5/8-11 ROD, Adjustment WASHER, 1/2 TRUNNION, Threaded WASHER, Detent INDICATOR, Height of Cut WASHER, 5/16 SCREW, Hex Washer Head, Taptite, 5/16-18 x 1 STRAP, Roller Support SCREW, Hex Washer Head, Taptite, 5/16-18 x 3/4 STOP, Up Wire NUT, Hex Adjusting LOCKWASHER, 3/4 NUT, Hex, 3/8-16 BAR, Roller SLIDE, Roller WASHER, 1/2 BOLT, Shoulder, 3/8-16 NUT, Push On NUT, Hex lock ESNA Heavy, 3/8 SPACER STRAP, Trunnion Retainer CAPSCREW, Hex Head, 3/8-16 x 1-3/4 G8 Footnotes: The above parts group applies to the following Mfg. Nos.: 1693585 1693575 40" Mower Deck, S/N Range 1 to 186 102 cm Mower Deck (Export), S/N Range 1 to 374 TP 400-2275-02-BR-SMA 45 40" (102 cm) Mower Deck – Height Adjustment & Rollers - (Later Models) NOTE: Unless noted otherwise, use the standard hardware torque specification chart. 20 21 19 20 21 47 21 21 20 5 48 1 20 20 21 2 48 20 11 3 12 10 48 20 13 4 14 15 48 20 21 16 20 9 47 21 18 8 17 7 6 20 21 22 23 24 24 46 25 16 26 29 27 28 45 30 32 33 34 31 31 16 Early 37 Models 36 32 11 44 43 43 38 35 39 40 41 21 22 43 20 21 42 The above parts group applies to the following Mfg. Nos.: 1693554 1693560 1693585 1693575 40" Mower Deck 40" Mower Deck 40" Mower Deck, S/N Range 186 and up 102 cm Mower Deck (Export), S/N Range 374 and up © Copyright 2001 Simplicity Manufacturing, Inc. All Rights Reserved. 46 TP 400-2275-02-BR-SMA 40" (102 cm) Mower Deck – Height Adjustment & Rollers - (Later Models) REF NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 PART NO. QTY. 1960093 1714084 1719901 916001 1704087 1706645 118053 1960074 1926149 1704083 1930644 1704116 1917356 1917372 1918448 1924940 1705049 176012 1686686 1924366 1717675 1931352 1719180 1915726 1719261 1960170 1704086 1704097 1719208 1919326 1919381 1665374 1664847 1719929 1704082 1916965 1916950 1704073 1677507 1924361 172622 1960520 960641 1706644 1704077 1922606 1709195 1668513 1 1 1 1 1 1 1 1 2 1 2 1 2 2 1 5 1 1 1 15 5 1 1 2 1 1 1 1 1 1 4 4 6 2 1 2 2 1 1 1 1 1 3 1 1 1 4 4 DESCRIPTION PAL NUT KNOB, Spinner CRANK, Height Adjust PIN, Spring TRUNNION, Rod TRUNNION, Bracket PIN, Round Head, Drilled, 3/8 x 2 CLIP, Hair Pin CAPSCREW, Hex Head, 5/16-18 x 1 G8 ARM, Rear Adjustable NUT, Hex Flagne Two-Way Lock, 1/2-13 BRACKET, Height of Cut LOCKWASHER, 5/16 NUT, Hex, 5/16-18 PIN, Cotter WASHER, 3/8 LINK & WELD PINS ASSEMBLY, Lower Lift RETAINER, Pin, Spring SHAFT & BAR ASSEMBLY, Roller WASHER, 5/8 ROLLER CARRIAGE BOLT, 3/8-16 x 1-1/2 SHAFT & ARMS ASSEMBLY, 40” Rear NUT, Hex, 5/8-11 ROD, Adjustment WASHER, 1/2 TRUNNION, Threaded WASHER, Detent INDICATOR, Height of Cut WASHER, 5/16 CAPSCREW, Hex Washer Head, Taptite, 5/16-18 x 1 STRAP, Roller Support CAPSCREW, Hex Washer Head, Taptite, 5/16-18 x 3/4 STOP, Up Wire NUT, Hex Adjusting LOCKWASHER, 3/4 (Early Models) NUT, Hex, 3/8-16 (Early Models) BAR, Roller SLIDE, Roller WASHER, 1/2 BOLT, Shoulder, 3/8-16 NUT, Push On NUT, Hex Lock Alum Insert, 3/8-16 (Later Models) SPACER STRAP, Trunnion Retainer CAPSCREW, Hex Head, 3/8-16 x 1-3/4 G8 SPACER ROLLER Footnotes: The above parts group applies to the following Mfg. Nos.: 1693554 1693560 1693585 1693575 40" Mower Deck 40" Mower Deck 40" Mower Deck, S/N Range 186 and up 102 cm Mower Deck (Export), S/N Range 374 and up TP 400-2275-02-BR-SMA 47 Part Number Index by Page Number Part No. Page No * * * * * * 101025 101096 101096 105337 106681 118053 118053 122023 156302 156302 157081 157081 158399 171600 171600 171600 171600 172329 172329 172353 172353 172434 172434 172622 172622 173477 174561 174561 174896 176012 176012 176440 176440 176440 176440 176440 912808 916001 916001 916168 916622 916964 920426 920427 920427 920427 920594 921319 923341 923471 923471 925094 927120 927794 6 10 10 10 10 32 26 40 42 6 8 44 46 24 40 42 40 42 16 18 34 36 38 40 42 28 28 6 20 44 46 28 8 14 16 44 46 2 4 8 16 18 28 44 46 16 24 26 26 6 14 24 26 26 26 34 36 24 38 8 Ref No. 9 76 77 78 79 16 33 2 2 22 26 7 7 16 21 21 6 6 21 25 31 31 31 19 19 5 18 27 4 42 41 16 12 26 18 18 18 32 11 25 9 10 6 4 4 15 17 19 15 16 10 21 22 18 25 21 21 4 21 24 Part No. Page No 927794 930598 930598 930670 932747 934683 960112 960202 960530 960641 960641 960644 1603618 1611705 1611710 1612103 1654930 1655729 1655729 1655729 1655777 1655777 1655777 1656916 1656916 1656916 1657242 1657242 1657528 1657969 1657969 1657969 1663114 1663136 1663752 1664090 1664847 1664847 1664847 1665237 1665238 1665374 1665374 1666697 1666697 1666697 1666697 1667346 1667811 1668513 1668819 1668819 1670675 1673453 1673796 1674358 1674671 1674671 1675044 1675044 28 6 24 4 24 6 6 28 2 42 46 38 26 4 28 26 20 34 36 38 34 36 38 34 36 38 40 42 34 34 36 38 14 8 20 28 34 44 46 26 26 44 46 2 8 40 42 6 14 46 24 26 18 6 4 24 40 42 36 38 Ref No. 20 17 22 36 2 1 10 13 30 34 43 10 17 27 9 29 23 6 6 6 16 16 16 3 3 3 12 12 17 5 5 5 1 42 7 3 22 34 33 13 12 33 32 8 44 28 28 6 25 48 18 14 20 7 16 1 26 26 17 17 Part No. Page No 1676130 1676183 1676278 1676278 1676519 1676519 1677247 1677247 1677296 1677370 1677371 1677507 1677507 1679385 1685215 1685290 1685478 1686686 1686734 1686784 1686784 1686784 1686817 1686817 1686817 1700229 1700229 1700229 1700230 1700230 1700230 1701229 1701229 1701435 1701435 1702779 1703240 1703248 1703249 1703273 1703273 1703273 1703475 1703508 1703513 1703799 1703900 1703945 1703946 1704073 1704073 1704077 1704077 1704082 1704082 1704083 1704083 1704086 1704086 1704087 © Copyright 2001 Simplicity Manufacturing, Inc. All Rights Reserved. 26 6 34 36 28 28 36 38 26 18 18 44 46 2 26 26 4 46 26 34 36 38 34 36 38 34 36 38 34 36 38 20 24 28 28 4 18 18 18 34 36 38 2 4 4 26 8 18 18 44 46 44 46 44 46 44 46 44 46 44 48 Ref No. 5 31 8 8 10 21 33 33 21 40 37 40 39 28 26 11 24 19 3 25 25 25 32 32 32 15 15 15 14 14 14 33 6 8 19 21 1 36 38 9 9 9 33 9 14 10 4 35 39 39 38 46 45 36 35 10 10 28 27 5 Part No. Page No 1704087 1704097 1704097 1704108 1704112 1704116 1704116 1704299 1704311 1704314 1704349 1704351 1704357 1704379 1704419 1704420 1704420 1704425 1704614 1704623 1704626 1704628 1704629 1704632 1704723 1704724 1704728 1704756 1704878 1704879 1704927 1705049 1705049 1705248 1705249 1705590 1706553 1706644 1706644 1706645 1706645 1706956 1706996 1706997 1707137 1707232 1707334 1707335 1707335 1707335 1707471 1707789 1707839 1707879 1707912 1708007 1708084 1708236 1708264 1708298 46 44 46 20 26 44 46 20 2 2 26 2 6 24 6 4 14 16 26 16 18 18 14 26 20 20 20 14 18 18 18 44 46 18 18 16 8 44 46 44 46 4 4 4 20 24 6 34 36 38 20 10 10 10 10 22 4 4 6 2 Ref No. 5 29 28 24 28 12 12 13 26 31 27 23 33 13 18 30 29 10 32 7 31 32 12 23 38 19 36 16 34 22 15 17 17 29 28 3 37 45 44 6 6 31 32 28 16 20 3 7 7 7 28 6 15 49 47 6 23 18 26 17 Part No. Page No 1708361 1708649 1708650 1708651 1708653 1708667 1708673 1708689 1708691 1708692 1708764 1708927 1708927 1709188 1709195 1709238 1709256 1709307 1709308 1709856 1709950 1713091 1713091 1713091 1713163 1713163 1713166 1713167 1713170 1713187 1713447 1713578 1713578 1713846 1713855 1714068 1714084 1714084 1714255 1714400 1714441 1714770 1715025 1715032 1715308 1715435 1715435 1715759 1715759 1715834 1715835 1715917 1716128 1716132 1716332 1717163 1717186 1717425 1717451 1717519 20 10 10 10 10 10 10 10 10 10 6 30 32 18 46 18 20 20 20 28 14 34 36 38 24 26 28 28 28 6 2 40 42 6 16 6 44 46 8 4 20 24 16 28 4 40 42 40 42 14 14 20 18 28 26 26 14 8 28 18 Ref No. 31 16 13 12 17 21 24 53 9 50 15 2 2 7 47 21 17 2 14 11 41 11 11 11 19 30 2 4 15 21 14 20 20 12 11 13 2 2 36 1 37 7 16 7 25 13 13 22 22 4 5 21 27 17 6 34 43 27 14 2 TP 400-2275-02-BR-S Part Number Index by Page Number Part No. Page No 1717549 1717550 1717675 1717675 1717692 1717692 1717706 1717706 1717749 1717749 1717765 1717767 1717769 1717936 1717989 1718014 1718016 1718052 1718053 1718054 1718055 1718061 1718069 1718070 1718071 1718073 1718076 1718077 1718078 1718079 1718080 1718081 1718083 1718084 1718086 1718087 1718088 1718089 1718097 1718100 1718101 1718102 1718103 1718104 1718107 1718109 1718110 1718111 1718112 1718113 1718114 1718115 1718117 1718119 1718120 1718121 1718122 1718219 1718508 1718508 26 26 44 46 30 32 30 32 10 28 14 14 14 2 16 14 14 10 10 10 10 10 10 10 10 10 10 10 10 10 10 10 10 10 10 10 10 10 10 10 10 10 10 10 10 10 10 10 10 10 10 10 10 10 10 10 10 16 30 32 Ref No. 8 9 22 21 13 14 3 3 75 12 2 42 31 1 4 17 28 2 3 4 5 11 74 19 20 22 25 26 27 28 29 30 32 33 35 36 37 38 45 51 52 54 55 56 59 61 62 63 64 65 66 67 71 69 39 72 73 8 4 4 TP 400-2275-02-BR-S Part No. Page No 1718596 1718678 1718856 1718858 1718944 1719180 1719180 1719206 1719208 1719208 1719221 1719221 1719253 1719261 1719261 1719268 1719269 1719271 1719312 1719351 1719355 1719392 1719471 1719543 1719562 1719562 1719679 1719681 1719712 1719731 1719736 1719736 1719736 1719737 1719737 1719737 1719739 1719766 1719766 1719766 1719809 1719810 1719842 1719845 1719862 1719862 1719862 1719901 1719901 1719902 1719923 1719923 1719929 1719929 1719939 1719940 1719965 1719965 1719966 1719972 26 6 2 20 14 44 46 20 44 46 40 42 8 44 46 8 8 14 8 22 2 20 4 44 40 42 20 24 20 2 34 36 38 34 36 38 18 34 36 38 20 4 40 18 34 36 38 44 46 8 40 42 44 46 22 16 40 42 2 2 Ref No. 24 11 34 8 3 24 23 22 30 29 16 16 43 26 25 6 32 21 30 14 2 35 3 19 15 15 29 3 39 10 24 24 24 18 18 18 4 4 4 4 15 4 4 18 12 12 12 3 3 23 27 27 35 34 2 23 7 7 5 24 Part No. Page No 1719978 1719981 1719985 1719988 1719989 1719990 1719993 1719999 1719999 1720001 1720007 1720008 1720009 1720010 1720011 1720013 1720017 1720018 1720019 1720020 1720022 1720036 1720041 1720044 1720044 1720083 1720099 1720108 1720109 1720110 1720117 1720118 1720119 1720120 1720122 1720223 1720224 1720232 1720233 1720326 1720327 1720328 1720329 1720389 1720390 1720391 1720392 1720401 1720412 1720412 1720417 1720418 1720419 1720420 1720424 1720425 1720426 1720439 1720440 1720441 18 16 34 16 16 16 8 24 26 24 14 22 22 22 22 22 6 8 8 22 8 8 2 40 42 22 28 8 6 6 26 24 24 24 4 14 14 16 14 18 18 18 18 32 32 32 32 24 30 32 10 10 10 10 10 10 10 10 10 10 49 Ref No. 17 22 19 17 14 19 19 5 2 15 6 16 18 11 17 10 8 38 1 1 39 46 3 23 23 13 22 34 35 28 1 14 11 12 12 44 19 12 13 8 6 9 3 5 6 7 8 8 8 9 7 8 10 14 23 31 34 57 58 60 Part No. Page No 1720442 1720444 1720444 1720447 1720454 1720454 1720458 1720460 1720460 1720504 1720504 1720505 1720505 1720507 1720532 1720587 1720658 1720660 1720661 1720724 1720882 1721107 1721108 1721111 1721117 1721117 1721133 1721141 1721141 1721146 1721153 1721153 1721153 1721154 1721169 1721171 1721172 1721174 1721175 1721176 1721177 1721178 1721179 1721181 1721182 1721184 1721185 1721197 1721197 1721202 1721203 1721254 1721254 1721258 1721258 1721425 1721425 1721446 1721533 1721533 10 40 42 20 30 32 22 30 32 30 32 30 32 6 6 34 30 30 30 14 14 32 32 20 40 42 14 30 32 18 34 36 38 34 2 2 2 2 22 10 10 10 10 10 10 10 10 30 32 6 18 36 38 36 38 40 42 6 40 42 Ref No. 70 8 8 12 9 10 15 10 11 11 12 12 13 5 23 20 7 5 6 40 39 18 15 20 31 31 32 15 17 41 13 13 13 26 19 7 9 36 19 1 18 40 41 43 44 48 68 1 1 40 26 26 26 19 19 25 25 13 1 1 Part No. Page No 1721702 1721965 1721966 1721983 1721987 1722006 1722092 1722175 1722257 1722257 1722258 1722258 1722258 1722384 1722384 1722396 1722474 1722475 1915726 1915726 1916622 1916622 1916950 1916950 1916950 1916950 1916950 1916951 1916964 1916964 1916965 1916965 1916965 1916965 1916965 1917356 1917356 1917356 1917356 1917356 1917356 1917372 1917372 1917372 1917372 1917372 1918199 1918447 1918447 1918448 1918448 1919262 1919314 1919326 1919326 1919326 1919326 1919326 1919326 1919326 20 10 10 22 6 18 2 42 36 38 34 36 38 30 32 38 32 32 44 46 20 26 2 8 14 44 46 2 8 20 2 8 14 44 46 6 8 14 22 44 46 6 8 22 44 46 6 8 14 44 46 4 4 2 6 6 8 14 44 46 Ref No. 1 42 46 9 42 14 6 4 20 20 23 23 23 14 19 8 21 20 25 24 25 20 20 9 8 38 37 35 21 26 21 10 7 37 36 37 17 38 4 13 13 38 16 8 14 14 25 28 18 15 15 22 5 12 30 41 3 22 31 30 Part Number Index by Page Number Part No. Page No 1919381 1919381 1919381 1919381 1919438 1919438 1919438 1919438 1919438 1919439 1919439 1919439 1920263 1920283 1920397 1921210 1921221 1921319 1921319 1921319 1921332 1921333 1921719 1921968 1921968 1921969 1921969 1921971 1921971 1921971 1922127 1922606 1922606 1922611 1922694 1922694 1922694 1922694 1922755 1922755 1922755 1922755 1923325 1923360 1923362 1923500 1923701 1923701 1924356 1924361 1924361 1924366 1924366 1924856 1924856 1924856 1924874 1924940 1924940 1924940 8 16 22 46 4 8 14 16 20 20 40 42 26 22 18 8 4 18 20 24 22 6 8 4 4 40 42 14 40 42 8 44 46 14 8 40 42 44 4 14 40 42 8 16 14 44 40 42 16 44 46 44 46 34 36 38 8 6 8 14 Ref No. 18 5 7 31 17 41 15 6 18 6 3 3 16 3 16 7 13 19 27 9 5 39 33 15 26 18 18 27 14 14 13 47 46 35 35 32 32 44 19 34 10 10 2 13 37 20 30 30 2 41 40 21 20 27 27 27 40 19 11 24 Part No. Page No 1924940 1924940 1924940 1924940 1924940 1925003 1925003 1925003 1926149 1926149 1927428 1927557 1928352 1928352 1928352 1928352 1928352 1928721 1928721 1928957 1930584 1930585 1930585 1930594 1930598 1930601 1930601 1930601 1930601 1930601 1930644 1930644 1930645 1930810 1931277 1931335 1931335 1931337 1931339 1931339 1931342 1931350 1931350 1931350 1931352 1931352 1931352 1931353 1931648 1933263 1933263 1933263 1933263 1933896 1933896 1933896 1933896 1935041 1935048 1935048 20 40 42 44 46 18 20 24 44 46 18 2 4 14 20 40 42 4 4 40 38 34 36 18 6 2 18 20 40 42 44 46 4 8 2 8 22 14 20 20 6 2 4 20 8 44 46 14 20 34 36 38 42 18 34 36 38 2 8 8 Ref No. 5 5 5 16 16 12 32 10 9 9 11 15 10 23 10 17 17 34 35 9 1 10 10 42 20 13 33 34 29 29 11 11 20 29 27 45 12 11 3 40 32 25 8 9 8 23 22 33 11 2 2 2 33 23 29 29 29 22 5 14 Part No. Page No 1935255 1936228 1936723 1936723 1960020 1960020 1960027 1960043 1960044 1960070 1960074 1960074 1960074 1960093 1960093 1960096 1960096 1960096 1960096 1960114 1960136 1960160 1960170 1960170 1960223 1960223 1960270 1960295 1960295 1960339 1960353 1960368 1960368 1960369 1960370 1960373 1960373 1960373 1960373 1960373 1960373 1960404 1960404 1960404 1960459 1960519 1960519 1960520 1960520 1960529 1960536 1960536 1960540 1960547 1960590 1960590 1960613 1960614 1960615 1960615 © Copyright 2001 Simplicity Manufacturing, Inc. All Rights Reserved. 6 6 34 36 4 14 16 2 14 14 2 44 46 44 46 18 34 36 38 4 14 28 44 46 8 16 2 6 18 14 8 6 18 26 6 2 4 18 36 38 44 34 36 38 20 40 42 44 46 4 6 26 4 26 2 8 8 42 40 42 50 Ref No. 36 29 1 1 29 30 20 18 14 20 16 8 8 1 1 24 30 30 30 6 9 1 27 26 15 1 29 2 13 36 22 34 5 31 24 4 33 30 22 22 32 28 28 28 30 24 24 43 42 7 14 4 2 7 11 31 20 9 11 11 Part No. Page No 1960624 41686784 41686784 41686784 41703240 41704878 41704879 41719679 6 34 36 38 18 18 18 20 Ref No. Part No. Page No Ref No. 4 25 25 25 1 34 22 29 TP 400-2275-02-BR-S Hardware Identification & Torque Specifications Common Hardware Types Torque Specification Chart Hex Head Capscrew FOR STANDARD MACHINE HARDWARE (Tolerance ± 20%) Washer Hardware Grade Lockwasher Carriage Bolt No Marks SAE Grade 2 Hex Nut Size Of Hardware Standard Hardware Sizing 8-32 8-36 10-24 10-32 1/4-20 1/4-28 5/16-18 5/16-24 3/8-16 3/8-24 7/16-14 7/16-20 1/2-13 1/2-20 9/16-12 9/16-18 5/8-11 5/8-18 3/4-10 3/4-16 7/8-9 7/8-14 1-8 1-12 When a washer or nut is identified as 1/2”, this is the Nominal size, meaning the inside diameter is 1/2 inch; if a second number is present it represent the threads per inch When bolt or capscrew is identified as 1/2 - 16 x 2”, this means the Nominal size, or body diameter is 1/2 inch; the second number represents the threads per inch (16 in this example, and the final number is the body length of the bolt or screw (in this example 2 inches long). The guides and ruler furnished below are designed to help you select the appropriate hardware and tools. 0 1/4 Nut, 1/2” 1/2 Inside Diameter 3/4 1 1/4 1/2 3/4 Screw, 1/2 x 2 2 1/4 Body Diameter in/lbs ft/lbs 19 20 27 31 66 76 11 12 20 23 30 35 50 55 65 75 90 100 160 180 140 155 220 240 Nm. 2.1 2.3 3.1 3.5 7.6 8.6 15.0 16.3 27.2 31.3 40.8 47.6 68.0 74.8 88.4 102.0 122.4 136 217.6 244.8 190.4 210.8 299.2 326.4 SAE Grade 5 in/lbs ft/lbs 30 31 43 49 8 10 17 19 30 35 50 55 75 90 110 120 150 180 260 300 400 440 580 640 SAE Grade 8 Nm. in/lbs ft/lbs Nm. 3.4 3.5 4.9 5.5 10.9 13.6 23.1 25.8 40.8 47.6 68.0 74.8 102.0 122.4 149.6 163.2 204.0 244.8 353.6 408.0 544.0 598.4 788.8 870.4 41 43 60 68 12 14 25 27 45 50 70 80 110 120 150 170 220 240 386 420 600 660 900 1,000 4.6 4.9 6.8 7.7 16.3 19.0 34.0 34.0 61.2 68.0 95.2 108.8 149.6 163.2 204.0 231.2 299.2 326.4 525.0 571.2 816.0 897.6 1,244.0 1,360.0 NOTES 1. These torque values are to be used for all hardware excluding: locknuts, self-tapping screws, thread forming screws, sheet metal screws and socket head setscrews. 2. Recommended seating torque values for locknuts: a. for prevailing torque locknuts - use 65% of grade 5 torques. b. for flange whizlock nuts and screws - use 135% of grade 5 torques. 3. Unless otherwise noted on assembly drawings, all torque values must meet this specification. 1/2 Body Length 3/4 3 1/4 1/2 3/4 4 Wrench & Fastener Size Guide 1/4 5/16 3/8 1/4” Bolt or Nut Wrench—7/16” 5/16” Bolt or Nut Wrench—1/2” 3/8” Bolt or Nut Wrench—9/16” 7/16 DIA. 7/16” Bolt or Nut Wrench (Bolt)—5/8” Wrench (Nut)—11/16” 1/2 DIA. 1/2” Bolt or Nut Wrench—3/4”