Download Goodman Mfg GPC15 SEER User's Manual
Transcript
TECHNICAL MANU AL MANUAL GPC15 SEER Multi-Position Package Air Conditioners with R-410A • Refer to Service Manual RS6300008 for installation, operation, and troubleshooting information. • All safety information must be followed as provided in the Service Manual. • Refer to the appropriate Parts Catalog for part number information. • Models listed on page 3. • Models qualify for the 2009 and 2010 Federal Tax Credits for Energy Efficiency** **Note that these tax credits are subject to specific requirements set forth in the American Recovery and Reinvestment Act of 2009 and in the Internal Revenue Code. Goodman recommends that consumers consult a tax professional if they have questions about the applicability of these credits. This manual is to be used by qualified, professionally trained HVAC technicians only. Goodman does not assume any responsibility for property damage or personal injury due to improper service procedures or services performed by an unqualified person. Copyright © 2009 Goodman Manufacturing Company, L.P. RT6322008r3 August 2009 PRODUCT IDENTIFICATION The model and manufacturing number are used for positive identification of component parts used in manufacturing. Please use these numbers when requesting service or parts information. G P C 15 24 BRAND: ® G: Goodman Brand or Distinctions PRODUCT SERIES: 15: 15 SEER Rating PRODUCT FAMILY: C: Cooling H: Heat Pump 2 1 * * CONFIGURATION H: Horizontal M: Multi Position MAJOR REVISION: REFRIGERANT: 2: R-22 4: R-410A NOMINAL CAPACITY: 24: 24,000 BTUH 30: 30,000 BTUH 36: 36,000 BTUH 42: 42,000 BTUH 48: 48,000 BTUH VOLTAGE: 1: 208-230V/1ph/60Hz 3: 208-230v/3ph/60Hz 4: 460v/3ph/60Hz HIGH VOLTAGE! Disconnect ALL power before servicing or installing this unit. Multiple power sources may be present. Failure to do so may cause property damage, personal injury or death. Goodman will not be responsible for any injury or property damage arising from improper service or service procedures. If you install or perform service on this unit, you assume responsibility for any personal injury or property damage which may result. Many jurisdictions require a license to install or service heating and air conditioning equipment. WARNING 4 MINOR REVISION: PRODUCT TYPE: Package Cooling/Heating WARNING M Installation and repair of this unit should be performed ONLY by individuals meeting the requirements of an "entry level technician" as specified by the Air-Conditioning, Heating, and Refrigeration Institute (AHRI). Attempting to install or repair this unit without such background may result in product damage, personal injury or death. WARNING PRODUCT IDENTIFICATION The model and manufacturing number are used for positive identification of component parts used in manufacturing. Please use these numbers when requesting service or parts information. GPC1524M41A* GPC1530M41A* GPC1536M41A* GPC1542M41A* GPC1548M41A* Models qualify for the 2009 and 2010 Federal Tax Credits for Energy Efficiency** **Note that these tax credits are subject to specific requirements set forth in the American Recovery and Reinvestment Act of 2009 and in the Internal Revenue Code. Goodman recommends that consumers consult a tax professional if they have questions about the applicability of these credits. WARNING The United States Environmental Protection Agency (“EPA”) has issued various regulations regarding the introduction and disposal of refrigerants introduced into this unit. Failure to follow these regulations may harm the environment and can lead to the imposition of substantial fines. These regulations may vary by jurisdiction. Should questions arise, contact your local EPA office. Do not connect or use any device that is not design certified by Goodman for use with this unit. Serious property damage, personal injury, reduced unit performance and/or hazardous conditions may result from the use of such non-approved devices. WARNING To prevent the risk of property damage, personal injury, or death, do not store combustible materials or use gasoline or other flammable liquids or vapors in the vicinity of this appliance. WARNING 3 PRODUCT DESIGN GPC Package Cooling Units are designed for outdoor installations only in either residential or light commercial applications and are available in 2, 2-1/2, 3, 3-1/2 and 4 ton sizes. They are designed for 208/230 volt single phase applications. are a number of design characteristics which are different from the traditional reciprocating compressor. - Due to their design Scroll Compressors are inherently more tolerant of liquid refrigerant. NOTE: Even though the compressor section of a Scroll compressor is more tolerant of liquid refrigerant, continued floodback or flooded start conditions may wash oil from the bearing surfaces causing premature bearing failure. - Scroll Compressors use white oil which is compatible with 3GS oil which may be used if additional oil is required. - Operating pressures and amp draws may differ from standard reciprocating compressors. This information may be found in the "Cooling Performance Data" section. The connecting ductwork (Supply and Return) can be connected for either horizontal or vertical airflow. In the vertical application, a matching Roof Curb is recommended and a horizontal duct cover kit is required. A return air filter must be installed behind the return air grille(s) or provision must be made for a filter in an accessible location within the return air duct. The minimum filter area should not be less than those sizes listed in the Specification Section. Under no circumstances should the unit be operated without return air filters. A 3/4” PVC pipe is provided for removal of condensate water from the indoor coil In order to provide proper condensate flow, a drain trap is supplied and shipped loose inside the unit for field installation. (Do not reduce the drain line size.) Location and Clearances NOTE: To ensure proper condensate drainage, unit must be installed in a level position. Refrigerant flow control is achieved by use of restrictor orifices. GPC units use the FasTest Access Fitting System with a saddle that is either soldered to the suction and liquid lines or is fastened with a locking nut to the access fitting box (core) and then screwed into the saddle. Do not remove the core from the saddle until the refrigerant charge has been removed. Failure to do so could result in property damage or personal injury. The single phase units use permanent split capacitor (PSC) design compressors. Starting components are therefore not required for these units. A low microfarad run capacitor assists the compressor to start and remains in the circuit during operation. The outdoor fan motors are single phase capacitor type motors. GPC1524-48M41* units have X-13 indoor blower motors that are energized by a 24V signal from the thermostat and are constant torque motors with very low power consumption. The X-13 features an integral control module. Air for condensing (cooling cycle) is drawn through the outdoor coil by a propeller fan, and is discharged vertically out the top of the unit. The outdoor coil is designed for .0 static. No additional restriction (ductwork) shall be applied. Conditioned air is drawn through the filter(s), field installed, across the coil and back into the conditioned space by the indoor blower. GPC15 models use Copeland Scroll Compressors. There 4 48" MIN 12" MIN 36" MIN (FOR SERVICE) . 3" MIN 12" MIN 36" MIN (FOR SERVICE) Outside Slab Installation - Multi-positional (M) NOTE: Roof overhang should be no more than 36" and provisions made to deflect the warm discharge air out from the overhang. Minimum clearances are required to avoid air recirculation and keep the unit operating at peak efficiency. PRODUCT DESIGN WARNING TO PREVENT POSSIBLE PROPERTY DAMAGE, THE UNIT SHOULD REMAIN IN AN UPRIGHT POSITION DURING ALL RIGGING AND MOVING OPERATIONS. TO FACILITATE LIFTING AND MOVING IF A CRANE IS USED, PLACE THE UNIT IN AN ADEQUATE CABLE SLING. IMPORTANT: If using bottom discharge with roof curb, ductwork should be attached to the curb prior to installing the unit. Roof Curb Refer to Roof Curb Installation Instructions for proper curb installation. Curbing must be installed in compliance with the National Roofing Contractors Association Manual. Rooftop Installation - Multi-positional (M) NOTE: To ensure proper condensate drainage, unit must be installed in a level position. In installations where the unit is installed above ground level and not serviceable from the ground (Example: Roof Top installations), the installer must provide service platform for service person with rails or guards in accordance with local codes or ordinances or in their absence with the latest edition of the Uniform Mechanical Code Section 305. NOTE: Unit can also use roof curb (and platform for leveling, where necessary) to utilize bottom discharge. 5 PRODUCT DESIGN GPC15[24-48]M41* HKR ELECTRICAL DATA Circuit #1 Circuit #2 Minimum Circuit Ampacity at 208 / 240V Maximum Overcurrent Protection (amps) at 208 / 240V Minimum Circuit Ampacity at 208 / 240V Maximum Overcurrent Protection (amps) at 208 / 240V Actual kW & BTU at 240V GPC1524M41* HKR05A,CA HKR08A,CA HKR10A,CA 24 / 27 33 / 28 45 / 51 30 / 30 40 / 40 60 / 60 ---------- ---------- 4.75 / 16,200 7.00 / 23,800 9.50 / 32,400 GPC1530M41* HKR05A,CA HKR08A,CA HKR10A,CA 24 / 27 34 / 39 45 / 52 30 / 30 40 / 40 60 / 60 ---- ---- 4.75 / 16,200 7.0 / 23,800 9.5 / 32,400 Model and Heat Kit Usage HKR15A,CA 45 / 52 60 / 60 22 / 25 30 / 30 14.25 / 48,600 GPC1536M41* HKR05A,CA HKR08A,CA HKR10A,CA HKR15A,CA 24 / 27 34 / 39 45 / 52 45 / 52 30 / 30 40 / 40 60 / 60 60 / 60 ---------22 / 25 ---------30 / 30 4.75 / 16,200 7.00 / 23,800 9.50 / 32,400 14.25 / 48,600 GPC1542M41* HKR05A,CA HKR08A,CA 24 / 27 34 / 39 30 / 30 40 / 40 --- --- 4.75 / 16,200 7.0 / 23,800 HKR10A,CA HKR15A,CA 45 / 52 45 / 52 60 / 60 60 / 60 -22 / 25 -30 / 30 9.5 / 32,400 14.25 / 48,600 25 / 28 30 / 30 ---- ---- 4.75 / 16,200 34 / 40 46 / 53 40 / 40 60 / 60 ------- ------- 7.00 / 23,800 9.50 / 32,400 46 / 52 46 / 52 60 / 60 60 / 60 22 / 25 43 / 49 30 / 30 60 / 60 14.25 / 48,600 19.50 / 66,500 GPC1548M41* HKR05A,CA HKR08A,CA HKR10A,CA HKR15A,CA HKR20A,CA IMPORTANT NOTE: A separate power supply is required for the HKR heater kit. Heating kW Correction Factor Supply Votage 240 230 220 210 208 Correction Factor 1.0 0.93 0.85 0.78 0.76 Multiply rated kW by correction factor to get actual kW WARNING 6 All wires and overcurrent protection devices are sized for use with electric heaters only and without refrigeration. If heaters are not installed with above wire size, overheating and fire could occur. See PACKAGE COOLING SPECIFICATIONS section for minimum circuit ampacity and maximum overcurrent protection during refrigeration cycle. PRODUCT DIMENSIONS GPC15[24-48]M41* 47 51 POWER WIRE ENTRANCE 4 1/8 2 1/8 16 1 3/8 A? 5½ 16 6½ B 8 2 34 3 CONDENSATE DRAIN CONNECTION 3/4” NPT FEMALE SUPPLY B? SUCTION/LIQUID PRESSURE PORT 18 7/8 RETURN CONTROL WIRE ENTRANCE BLOWER ACCESS PANEL MEDIUM CHASSIS GPC1524M41* GPC1530M41* GPC1536M41* LARGE CHASSIS GPC1542M41* GPC1548M41* 7 GPC15[24-48]M41A* PACKAGE COOLING SPECIFICATIONS COOLING COOLING CAPACITY, BTUH CAPACITY SEER / EER UNIT VOLTAGE (NAMEPLATE) ELECTRICAL GPC1524M41* GPC1530M41* GPC1536M41* GPC1542M41* GPC1548M41* 24,000 28,000 35,000 40,000 45,500 14.5 / 12. 0 14.5 / 12. 0 14.5 / 12. 0 14.5 / 12. 0 15.0 / 12.0 208/230-60-1 208/230-60-1 208/230-60-1 208/230-60-1 208/230-60-1 AMPS 15.8 17.5 20.1 22.2 24.2 SPECIFICATION MIN CIRCUIT AMPACITY 19.0 21.0 24.2 26.7 29.2 30 35 40 40 45 SCROLL SCROLL SCROLL SCROLL SCROLL MAX OVERCURRENT PROTECTION COMPRESSOR TYPE RATED LOAD AMPS 12.8 14.1 16.7 17.9 19.9 LOCKED ROTOR AMPS 58.3 73.0 79.0 112.0 109.0 CONDENSER HORSEPOWER 1/6 1/4 1/4 1/4 1/4 FAN MOTOR RPM 815 837 837 1075 1075 FULL LOAD AMPS 1.1 1.5 1.5 1.4 1.4 LOCKED ROTOR AMPS 1.7 3.0 3.0 2.9 2.9 CONDENSER BLADE DIAMETER (INCHES) 22 22 22 22 22 FAN NUMBER OF BLADES 3 3 3 3 3 CONDENSER FACE AREA (SQ. FT.) 12.33 12.33 12.33 15.38 15.38 COIL NUMBER OF ROWS 1 2 2 2 2 FINS PER INCH 24 16 16 16 16 1/2 - 5 1/2 - 5 1/2 - 5 3/4 - 5 3/4 - 5 1.9 1.9 1.9 2.9 2.9 EVAPORATOR HORSEPOWER - NO. OF SPEEDS BLOWER FULL LOAD AMPS MOTOR LOCKED ROTOR AMPS --- --- --- --- --- MOTOR SPEED TAP-COOLING X-13 T2 T2 T2 T2 T2 RPM 1,050 1,050 1,050 1,050 1,050 EVAPORATOR DIAMETER X WIDTH (INCHES) 10 x 9 10 x 9 10 x 9 10 x 9 10 x 9 BLOWER RATED SCFM COOLING 850 1,050 1,150 1,350 1,350 MAX EXTERNAL STATIC PRESS ("w.c.) 0.5 0.5 0.5 0.5 0.5 EVAPORATOR FACE AREA (SQ. FT.) 4.52 4.52 4.52 6.17 6.17 COIL NUMBER OF ROWS 3 3 4 4 4 FINS PER INCH 16 16 14 14 14 GENERAL FILTER SIZE * 25 x 25 x 1 25 x 25 x 1 25 x 25 x 1 (2) 20 x 20 x 1 (2) 20 x 20 x 1 INFORMATION DRAIN SIZE (INCHES) 3/4" 3/4" 3/4" 3/4" 3/4" EXPANSION DEVICE 0.057 0.065 0.068 0.072 0.076 REFRIGERANT CHARGE R410A (OZS.) 80 100 115 140 170 POWER SUPPLY CONDUIT KNOCKOUT SIZE (INCHES) 3/4, 1, 1-1/4 3/4, 1, 1-1/4 3/4, 1, 1-1/4 3/4, 1, 1-1/4 3/4, 1, 1-1/4 LOW VOLTAGE CONDUIT KNOCKOUT SIZE (INCHES) 1/2 1/2 1/2 1/2 1/2 SHIPPING WEIGHT (LBS.) 375 384 416 459 459 OPERATING WEIGHT (LBS.) 354 363 395 438 438 (1) * Maximum Overcurrent Protection Device: MUST use Time Delay Fuse or HACR type Circuit Breaker of the same size as noted. Calculated external filter size based on air velocity of 300 ft/min. Wire size should be determined in accordance with National Electrical Codes. Extensive wire runs will require larger wire sizes. Unit specifications are subject to change without notice. ALWAYS refer to the units serial plate for the most up-to-date general and electrical information. IMPORTANT: While this data is presented as a guide, it is important to electrically connect the unit and properly size wires and fuses/circuit breakers in accordance with the National Electrical Code and/or all local codes. Data shown is w/o electric heaters. WARNING 8 All wires and overcurrent protection devices are sized for use with electric heaters only and without refrigeration. If heaters are not installed with above wire size, overheating and fire could occur. See PACKAGE COOLING SPECIFICATIONS section for minimum circuit ampacity and maximum overcurrent protection during refrigeration cycle. ACCESSORIES ACCESSORIES - GPC/GPH****M MODELS Part Number Description OT18-60A Outdoor Thermostat Kit w/Lockout Stat OT/EHR18-60 Emergency Heat Relay Kit HKR Electric Heat Kit PGC101/102/103 Roof Curb PEHH101/102 Horizontal Economizer For Heat Pump, Small and Medium Chassis PEHH103 Horizontal Economizer For Heat Pump, Large Chassis PEHC101/102 Horizontal Economizer For A/C, Small and Medium Chassis PEHC103 Horizontal Economizer For A/C, Large Chassis PGMDD101/102 Manual 25% Fresh Air Damper Downflow Application, Small and Medium Chassis PGMDD103 Manual 25% Fresh Air Damper Downflow Application, Large Chassis PGMDH102 Manual 25% Fresh Air Damper Horizontal Application, Medium Chassis PGMDH103 Manual 25% Fresh Air Damper Horizontal Application, Large Chassis PGMDMD101/102 Motorized 25% Fresh Air Damper Downflow Application,Small and Medium Chassis PGMDMD103 Motorized 25% Fresh Air Downflow Application, Large Chassis PGMDMH102 Motorized 25% Fresh Air Damper Horizontal Application, Medium Chassis PGMDMH103 Motorized 25% Fresh Air Damper Horizontal Application, Large Chassis GPC13MED102 Downflow Economizer For A/C, Medium Chassis GPC13MED103 Downflow Economizer For A/C, Large Chassis GPH13MED102 Downflow Economizer For Heat Pump, Medium Chassis GPH13MED103 Downflow Economizer For Heat Pump, Large Chassis GPH13MFR102 Internal Filter Rack, Medium Chassis GPH13MFR103 Internal Filter Rack, Large Chassis GPGHFR101-103 External Horizontal Filter Rack for Goodman/Amana Gas/Electric and Multi-position Package Units All Chassis SQRPG101/102 Square to Round Adapter w/ 16" Round Downflow Application, Medium Chassis SQRPG103 Square to Round Adapter w/ 18" Round Downflow Application, Large Chassis SQRPGH101/102 Square to Round Adapter w/ 16" Round Horizontal Application, Medium Chassis SQRPGH103 Square to Round Adapter w/ 18" Round Horizontal Application, Large Chassis CDK36 Flush Mount Concentric Duct Kit CDK36515 Flush Mount Concentric Duct Kit w/ Filter CDK36530 Step Down Concentric Duct Kit CDK36535 Step Down Concentric Duct Kit w/ Filter CDK4872 Flush Mount Concentric Duct Kit CDK4872515 Flush Mount Concentric Duct Kit w/ Filter CDK4872530 Step Down Concentric Duct Kit CDK4872535 Step Down Concentric Duct Kit w/ Filter 9 BLOWER PERFORMANCE DATA GPC15[24-48]M41A* Dry Coil Data GPC1536M41* GPC1530M41* GPC1524M41* Model Speed T1 (G) 230 T4 / T5 230 T1 (G) 230 T2 / T3 230 T4 / T5 230 T2 / T3 GPC1542M41* T4 / T5 T1 (G) T2 / T3 T4 / T5 GPC1548M41* 230 T2 / T3 T1 (G) T1 (G) T2 / T3 T4 / T5 E.S.P (In. of H2 O) Volts 230 230 230 230 230 230 230 230 230 0.1 0.2 0.3 0.4 0.5 0.6 0.7 0.8 CFM 882 808 727 649 545 --- --- --- WATTS 82 86 92 102 108 --- --- --- CFM 933 873 810 733 637 584 --- --- WATTS 93 103 109 120 126 135 --- --- CFM 1058 1012 945 896 816 723 672 --- WATTS 124 136 142 153 168 172 179 --- CFM 893 824 752 665 575 --- --- --- WATTS 87 95 101 111 115 --- --- --- CFM 1132 1070 1011 959 889 827 733 669 WATTS 153 162 168 179 184 195 206 208 CFM 1287 1236 1165 1123 1066 1012 958 857 WATTS 211 217 228 239 244 255 265 272 CFM 852 764 711 592 545 --- --- --- WATTS 80 82 85 95 99 --- --- --- CFM 1232 1190 1131 1082 1023 966 889 819 WATTS 202 214 221 229 235 246 258 264 CFM 1267 1213 1162 1120 1058 1009 932 841 WATTS 218 226 236 245 247 260 272 275 CFM 1123 1070 1025 984 942 894 839 774 Watts 162 170 182 193 204 216 229 242 CFM 1437 1390 1354 1318 1281 1243 1204 1165 Watts 310 317 331 342 355 366 377 389 CFM 1528 1490 1450 1410 1383 1348 1312 1267 Watts 372 379 391 403 416 427 439 451 CFM 1199 1138 1085 1017 957 889 820 755 WATTS 162 173 185 193 211 219 232 245 CFM 1799 1745 1698 1658 1610 1560 1522 1450 WATTS 480 493 508 521 531 545 550 547 CFM 1921 1865 1818 1780 1719 1667 1579 1483 WATTS 582 585 602 625 627 621 595 569 NOTES: • • • • 10 Data shown is Dry Coil. Wet Coil Pressure Drop is approximate. 0.1" H2O, for 2 row indoor coil; 0.2” H2O, for 3 row indoor coil; and 0.3” H2O, for 4 row indoor coil. Data shown does not include filter pressure drop, approx. 0.08” H2O. ALL MODELS SHOULD RUN NO LESS THAN 350 CFM / TON. Reduce airflow by 2% for 208V operation. TEMPERATURE RISE 10 20 30 40 50 60 70 30 80 90 100 40 50 60 700 600 CFM 90 100 2000 2200 2400 CFM 1800 1600 1400 OUTPUT BTU/HR x 1000 80 1200 1100 1000 900 70 800 FORMULAS 110 120 130 140 BTU OUTPUT = CFM x 1.08 x RISE BTU OUTPUT RISE = ÷ CFM 1.08 BTU OUTPUT vs TEMPERATURE RISE CHART 150 BLOWER PERFORMANCE DATA 11 12 MODEL: GPC1524M41 EXPANDED PERFORMANCE DATA 21.7 0.67 18 1.45 7.2 239 105 24.7 0.82 20 1.53 7.5 251 110 23.9 0.79 20 1.51 7.4 249 109 22.1 0.76 21 1.47 7.2 241 106 MBh S/T Delta T KW AMPS HI PR LO PR MBh S/T Delta T KW AMPS HI PR LO PR MBh S/T Delta T KW AMPS HI PR LO PR MBh S/T Delta T KW AMPS HI PR LO PR 850 744 956 850 744 22.8 0.68 19 1.51 7.4 260 112 24.7 0.70 19 1.56 7.6 268 116 25.4 0.74 18 1.57 7.6 271 117 22.5 0.56 15 1.49 7.3 257 111 24.4 0.58 15 1.54 7.5 265 115 24.6 0.51 16 1.57 7.6 274 123 26.7 0.53 15 1.62 7.8 283 127 27.5 0.56 15 1.63 7.8 286 128 24.7 0.39 12 1.55 7.5 272 121 26.7 0.40 12 1.60 7.7 280 125 26.4 0.33 11 1.63 7.8 286 131 28.6 0.34 11 1.68 8.0 295 135 29.5 0.36 10 1.70 8.1 298 136 - - 21.6 0.78 21 1.61 7.7 271 112 23.4 0.81 21 1.66 7.9 279 115 24.1 0.85 20 1.68 8.0 282 116 21.2 0.69 18 1.60 7.7 268 111 23.0 0.72 18 1.65 7.9 277 114 22.2 0.70 19 1.66 7.9 292 119 24.1 0.73 19 1.71 8.1 301 122 24.8 0.76 18 1.73 8.1 304 124 22.0 0.58 16 1.64 7.8 289 118 23.8 0.60 15 1.69 8.0 298 121 24.1 0.53 16 1.72 8.1 308 130 26.1 0.55 16 1.78 8.3 317 134 26.8 0.58 15 1.80 8.4 321 135 24.1 0.40 12 1.71 8.0 305 128 26.1 0.41 12 1.76 8.2 314 132 25.8 0.34 11 1.79 8.4 321 138 28.0 0.35 11 1.85 8.6 331 142 28.8 0.37 10 1.87 8.7 334 144 - - 21.1 0.80 21 1.74 8.3 308 116 22.8 0.83 21 1.80 8.5 318 120 23.5 0.88 20 1.81 8.6 321 121 20.7 0.71 18 1.72 8.2 305 115 22.4 0.73 18 1.78 8.4 314 118 21.7 0.72 19 1.79 8.5 332 123 23.5 0.75 19 1.85 8.7 342 127 24.2 0.78 18 1.86 8.8 345 129 21.5 0.59 16 1.77 8.4 328 122 23.3 0.61 15 1.83 8.6 338 126 23.5 0.54 16 1.86 8.7 350 135 25.4 0.56 16 1.92 8.9 361 139 26.2 0.59 15 1.94 9.0 365 140 23.5 0.41 12 1.84 8.7 347 133 25.5 0.42 12 1.90 8.9 357 138 - - 25.2 0.35 11 1.94 9.0 365 144 27.3 0.36 11 2.00 9.2 377 148 28.1 0.38 10 2.02 9.3 380 149 * Entering Indoor Dry Bulb Temperature NOTE: Shaded area is ACCA (TVA) conditions High and low pressures are measured at the liquid and suction access fittings. 75 70 23.5 0.69 18 1.50 7.3 246 108 MBh S/T Delta T KW AMPS HI PR LO PR 20.6 0.83 21 1.86 8.8 351 122 22.3 0.86 21 1.91 9.0 362 126 22.9 0.90 20 1.93 9.1 365 127 20.2 0.73 18 1.84 8.7 347 121 21.9 0.76 18 1.89 8.9 358 124 21.2 0.74 19 1.91 9.0 378 130 22.9 0.56 16 1.98 9.3 399 142 24.8 0.58 16 2.04 9.5 411 146 25.6 0.61 15 2.07 9.6 415 147 23.6 0.81 18 1.99 9.3 393 135 22.9 0.77 19 1.97 9.2 389 134 23.0 0.42 12 1.96 9.2 395 140 24.9 0.44 12 2.02 9.4 407 144 21.0 0.61 16 1.89 8.9 374 128 22.7 0.63 16 1.95 9.1 385 132 24.6 0.36 11 2.06 9.6 416 151 26.6 0.38 11 2.13 9.8 429 155 27.4 0.39 10 2.15 9.9 433 157 - - 19.5 0.86 21 1.95 9.3 395 128 21.2 0.89 20 2.01 9.5 407 132 21.8 0.94 20 2.03 9.6 411 133 19.2 0.76 18 1.93 9.2 391 126 20.8 0.79 18 1.99 9.5 403 130 20.1 0.77 19 2.00 9.5 425 136 21.8 0.80 19 2.07 9.7 438 140 22.4 0.84 18 2.09 9.8 442 141 19.9 0.63 16 1.98 9.4 421 135 21.6 0.66 15 2.05 9.7 434 139 21.8 0.58 16 2.09 9.8 449 148 23.6 0.61 15 2.15 10.0 463 153 24.3 0.63 15 2.17 10.1 467 154 21.8 0.44 12 2.06 9.7 444 147 23.6 0.46 12 2.13 10.0 458 151 Design Subcooling, 7 °F @ the liquid access fitting connection AHRI 95 test conditions. Design Superheat 5°F @ the compressor suction access fitting connection. Outdoor Ambient Temperature 65 75 85 95 105 Entering Indoor Wet Bulb Temperature IDB* Airflow 59 63 67 71 59 63 67 71 59 63 67 71 59 63 67 71 59 63 67 MBh 24.3 25.1 27.5 23.7 24.6 26.9 23.1 24.0 26.3 22.6 23.4 25.6 21.4 22.2 24.3 S/T 0.72 0.60 0.42 0.75 0.63 0.43 0.77 0.64 0.45 0.79 0.66 0.46 0.82 0.69 0.48 Delta T 17 15 11 17 15 11 17 15 11 17 15 11 17 15 11 956 KW 1.51 1.55 1.62 1.66 1.71 1.78 1.80 1.85 1.92 1.91 1.97 2.04 2.01 2.07 2.15 AMPS 7.4 7.6 7.8 7.9 8.1 8.3 8.5 8.7 8.9 9.0 9.2 9.5 9.5 9.7 10.0 HI PR 249 268 283 279 301 317 318 342 361 362 389 411 407 438 463 LO PR 109 116 126 115 122 134 120 127 139 126 134 146 132 140 153 23.4 0.38 11 2.17 10.1 468 158 25.3 0.39 11 2.24 10.4 482 163 26.1 0.41 10 2.26 10.5 487 164 - - 71 - 18.1 0.87 19 2.04 9.8 436 132 19.6 0.90 19 2.10 10.0 450 136 20.2 0.95 18 2.12 10.1 454 138 17.8 0.76 17 2.01 9.7 432 131 19.3 0.79 17 2.08 10.0 445 135 59 19.9 0.83 16 2.10 10.0 450 136 18.6 0.78 18 2.09 10.0 470 141 20.2 0.81 18 2.16 10.3 484 145 20.8 0.85 17 2.18 10.4 489 146 18.4 0.64 15 2.07 9.9 465 139 20.0 0.66 14 2.13 10.2 479 143 63 20.6 0.69 14 2.16 10.3 484 145 20.2 0.59 15 2.17 10.3 496 153 21.8 0.61 14 2.24 10.6 511 158 22.5 0.64 14 2.27 10.7 516 160 20.2 0.44 11 2.15 10.2 491 152 21.9 0.46 11 2.22 10.5 506 157 67 22.5 0.48 10 2.24 10.6 511 158 115 21.6 0.38 10 2.26 10.7 517 163 23.4 0.39 10 2.33 10.9 533 168 24.1 0.41 10 2.36 11.0 538 170 - - 71 - COOLING OPERATION COOLING PERFORMANCE DATA GPC1524M41* MODEL: GPC1524M41 EXPANDED PERFORMANCE DATA 22.5 0.83 23 1.48 7.3 244 107 25.5 0.95 23 1.56 7.6 257 112 24.8 0.90 24 1.54 7.5 254 111 22.9 0.87 25 1.50 7.3 246 108 MBh S/T Delta T KW AMPS HI PR LO PR MBh S/T Delta T KW AMPS HI PR LO PR MBh S/T Delta T KW AMPS HI PR LO PR MBh S/T Delta T KW AMPS HI PR LO PR 850 744 956 850 744 23.3 0.84 24 1.54 7.5 265 115 25.3 0.87 24 1.59 7.7 273 118 26.0 0.91 23 1.60 7.7 276 119 23.0 0.78 22 1.52 7.4 262 114 24.9 0.81 22 1.57 7.6 271 117 24.4 0.76 23 1.60 7.7 280 125 26.5 0.79 23 1.65 7.9 289 129 27.3 0.82 22 1.67 7.9 292 130 24.6 0.63 19 1.58 7.6 277 124 26.6 0.66 19 1.63 7.8 286 128 26.1 0.62 20 1.67 7.9 292 133 28.2 0.64 19 1.72 8.1 301 137 29.1 0.67 19 1.74 8.2 304 139 26.3 0.47 15 1.65 7.9 289 132 28.4 0.49 15 1.70 8.1 298 136 22.4 0.90 25 1.65 7.8 276 114 24.2 0.94 25 1.70 8.0 285 117 24.9 0.98 24 1.72 8.1 288 119 22.0 0.86 23 1.63 7.8 274 113 23.8 0.89 23 1.68 8.0 282 116 22.8 0.87 25 1.69 8.0 297 121 24.7 0.90 24 1.74 8.2 307 125 25.4 0.95 23 1.76 8.3 310 126 22.4 0.81 22 1.67 8.0 295 120 24.3 0.84 22 1.73 8.1 304 124 23.9 0.79 23 1.76 8.2 314 132 25.9 0.81 23 1.82 8.4 324 136 26.6 0.85 22 1.83 8.5 327 138 24.0 0.66 19 1.74 8.2 311 131 26.0 0.68 19 1.80 8.4 321 135 25.5 0.64 20 1.83 8.5 328 141 27.6 0.66 20 1.89 8.7 338 145 28.4 0.69 19 1.91 8.8 341 147 25.6 0.49 16 1.81 8.4 324 139 27.8 0.51 15 1.87 8.7 334 144 21.8 0.93 25 1.78 8.4 314 118 23.6 0.96 25 1.83 8.6 324 122 24.4 1.00 23 1.85 8.7 327 123 21.4 0.88 23 1.76 8.4 311 117 23.2 0.92 23 1.82 8.6 321 121 22.2 0.89 25 1.83 8.6 338 126 24.1 0.93 24 1.88 8.8 349 130 24.8 0.97 23 1.90 8.9 352 131 21.9 0.83 22 1.81 8.5 335 125 NOTE: 23.7 0.86 22 1.86 8.8 345 129 27.1 0.52 15 2.02 9.3 380 149 22.7 0.94 23 1.93 9.1 366 127 23.2 0.89 22 1.99 9.3 393 135 24.7 0.72 19 2.07 9.6 415 147 26.5 0.54 15 2.15 9.9 433 157 23.3 0.81 23 1.90 8.9 357 137 25.2 0.84 23 1.96 9.1 368 142 26.0 0.88 22 1.98 9.2 372 143 24.9 0.65 20 1.98 9.2 373 146 26.9 0.68 20 2.04 9.4 384 151 27.7 0.71 19 2.06 9.5 388 152 21.3 0.96 25 1.89 8.9 358 124 23.1 0.99 25 1.95 9.2 369 128 23.8 1.00 23 1.97 9.2 373 129 21.7 0.92 25 1.94 9.1 385 132 23.5 0.96 24 2.01 9.4 397 136 24.2 1.00 23 2.03 9.4 401 138 22.7 0.83 23 2.02 9.4 407 144 24.6 0.86 23 2.09 9.6 420 149 25.4 0.90 22 2.11 9.7 424 150 20.2 0.99 25 1.99 9.5 403 130 21.9 1.00 24 2.05 9.7 415 134 22.6 1.00 22 2.08 9.8 419 136 19.9 0.95 23 1.97 9.4 399 129 21.5 0.98 23 2.03 9.6 411 133 20.6 0.96 24 2.05 9.7 434 139 22.3 0.99 24 2.11 9.9 447 143 23.0 1.00 22 2.13 10.0 451 144 20.3 0.89 22 2.03 9.6 429 137 22.0 0.92 22 2.09 9.8 443 141 21.6 0.86 23 2.13 10.0 458 151 23.4 0.90 23 2.20 10.2 472 156 24.1 0.94 22 2.22 10.3 477 158 21.7 0.72 19 2.11 9.9 453 150 23.5 0.75 19 2.17 10.1 467 154 23.0 0.70 20 2.22 10.3 477 161 25.0 0.73 20 2.28 10.6 492 166 25.7 0.76 19 2.31 10.6 497 168 23.2 0.54 15 2.19 10.2 473 160 25.1 0.56 15 2.26 10.5 487 165 71 25.9 0.59 15 2.28 10.6 492 166 18.7 1.00 23 2.08 10.0 445 135 20.3 1.00 22 2.14 10.2 459 139 20.9 1.00 20 2.16 10.3 463 140 18.4 0.95 22 2.06 9.9 441 133 19.9 0.99 21 2.12 10.1 454 138 59 20.5 1.00 20 2.14 10.2 459 139 19.1 0.96 23 2.13 10.2 479 143 20.7 1.00 22 2.20 10.4 494 148 21.3 1.00 20 2.22 10.5 499 149 18.8 0.89 21 2.11 10.1 474 142 20.4 0.93 20 2.18 10.4 489 146 63 21.0 1.00 20 2.20 10.4 494 148 20.0 0.87 22 2.22 10.5 506 157 21.7 0.90 21 2.29 10.8 521 161 22.3 0.95 20 2.31 10.8 527 163 20.1 0.73 18 2.20 10.4 501 155 21.8 0.75 18 2.27 10.7 516 160 67 22.4 0.79 17 2.29 10.8 521 161 115 21.3 0.71 19 2.31 10.8 528 167 23.1 0.73 18 2.38 11.1 544 172 23.8 0.77 18 2.41 11.2 549 174 21.5 0.54 14 2.29 10.8 522 165 23.3 0.56 14 2.36 11.0 538 170 71 24.0 0.59 14 2.38 11.1 544 172 COOLING OPERATION KW = Total system power AMPS: Unit amps (comp.+ evaporator + condenser fan motors) 24.2 0.67 20 2.11 9.7 424 154 26.3 0.70 20 2.17 10.0 438 159 27.1 0.73 19 2.19 10.1 442 160 23.4 25.0 20.9 21.4 22.8 24.4 0.67 0.50 0.91 0.85 0.70 0.52 19 16 24 23 20 16 1.88 1.96 1.87 1.93 2.00 2.08 8.8 9.1 8.9 9.1 9.3 9.6 354 369 355 382 403 420 136 145 123 131 143 152 Shaded area reflects AHRI rating conditions 25.4 0.70 19 1.94 9.0 365 140 * Entering Indoor Dry Bulb Temperature NOTE: Shaded area is AHRI Rating Conditions High and low pressures are measured at the liquid and suction access fittings. 85 80 24.4 0.86 23 1.53 7.5 251 110 MBh S/T Delta T KW AMPS HI PR LO PR Design Subcooling, 7 °F @ the liquid access fitting connection AHRI 95 test conditions. Design Superheat 5°F @ the compressor suction access fitting connection. Outdoor Ambient Temperature 65 75 85 95 105 Entering Indoor Wet Bulb Temperature IDB* Airflow 59 63 67 71 59 63 67 71 59 63 67 71 59 63 67 71 59 63 67 MBh 25.1 25.6 27.4 29.3 24.5 25.1 26.8 28.6 23.9 24.5 26.1 27.9 23.3 23.9 25.5 27.2 22.2 22.7 24.2 S/T 0.90 0.85 0.69 0.52 0.94 0.88 0.71 0.53 0.96 0.90 0.73 0.55 1.00 0.93 0.76 0.57 1.00 0.96 0.78 Delta T 22 21 18 15 22 21 18 15 22 21 18 15 22 21 19 15 21 21 18 956 KW 1.54 1.59 1.65 1.72 1.70 1.74 1.82 1.89 1.83 1.88 1.96 2.04 1.95 2.01 2.09 2.17 2.05 2.11 2.20 AMPS 7.5 7.7 7.9 8.1 8.0 8.2 8.4 8.7 8.6 8.8 9.1 9.4 9.2 9.4 9.6 10.0 9.7 9.9 10.2 HI PR 254 273 289 301 285 307 324 338 324 349 368 384 369 397 420 438 415 447 472 LO PR 111 118 129 137 117 125 136 145 122 130 142 151 128 136 149 159 134 143 156 COOLING PERFORMANCE DATA GPC1524M41* 13 14 MODEL: GPC1530M41 EXPANDED PERFORMANCE DATA 25.0 0.67 17 1.65 8.3 223 104 28.4 0.83 18 1.74 8.6 234 109 27.6 0.79 19 1.72 8.5 232 108 25.4 0.76 19 1.67 8.4 225 105 MBh S/T Delta T KW AMPS HI PR LO PR MBh S/T Delta T KW AMPS HI PR LO PR MBh S/T Delta T KW AMPS HI PR LO PR MBh S/T Delta T KW AMPS HI PR LO PR 1050 919 1181 1050 919 26.2 0.68 18 1.71 8.5 242 111 28.4 0.71 18 1.77 8.7 249 115 29.2 0.74 17 1.78 8.8 252 116 25.9 0.56 15 1.70 8.5 240 110 28.1 0.58 14 1.75 8.6 247 114 28.3 0.52 15 1.78 8.7 256 121 30.7 0.54 14 1.83 8.9 263 125 31.6 0.56 14 1.85 9.0 266 126 28.4 0.39 11 1.76 8.7 253 120 30.8 0.40 11 1.82 8.9 261 124 30.4 0.33 10 1.85 9.0 267 129 33.0 0.35 10 1.91 9.2 275 133 33.9 0.36 10 1.93 9.3 278 135 - - 24.8 0.79 20 1.83 8.9 252 110 26.9 0.82 19 1.89 9.1 260 114 27.7 0.86 19 1.90 9.2 263 115 24.4 0.70 17 1.81 8.8 250 109 26.5 0.72 17 1.87 9.0 258 113 25.6 0.71 18 1.88 9.1 272 118 27.7 0.73 18 1.94 9.3 280 121 28.5 0.77 17 1.96 9.3 283 122 25.3 0.58 15 1.86 9.0 269 116 27.4 0.60 14 1.92 9.2 277 120 * IDB: Entering Indoor Dry Bulb Temperature High and low pressures are measured at the liquid and suction access fittings. 75 70 27.1 0.70 17 1.70 8.5 230 107 MBh S/T Delta T KW AMPS HI PR LO PR 29.7 0.34 10 2.03 9.6 299 137 32.2 0.36 10 2.09 9.8 308 141 33.2 0.37 10 2.11 9.9 311 142 - - 24.2 0.81 20 1.97 9.5 287 115 26.3 0.84 19 2.03 9.7 296 118 27.1 0.88 19 2.05 9.8 299 120 23.8 0.71 17 1.95 9.4 284 114 25.8 0.74 17 2.01 9.7 293 117 25.0 0.73 18 2.02 9.7 309 122 27.0 0.75 18 2.09 9.9 318 126 27.9 0.79 17 2.11 10.0 322 127 24.7 0.60 15 2.00 9.6 306 121 26.8 0.62 15 2.07 9.9 315 125 27.0 0.55 15 2.10 10.0 326 133 29.3 0.57 15 2.17 10.2 336 138 30.2 0.60 14 2.19 10.3 340 139 27.1 0.41 11 2.08 9.9 323 132 29.3 0.43 11 2.15 10.1 333 136 29.0 0.35 10 2.19 10.3 340 142 31.4 0.37 10 2.26 10.5 351 146 32.4 0.38 10 2.28 10.6 354 148 - - 23.7 0.84 20 2.10 10.1 327 121 25.6 0.87 20 2.16 10.3 337 124 26.4 0.91 19 2.18 10.4 340 126 23.3 0.74 17 2.08 10.0 324 119 25.2 0.76 17 2.14 10.2 334 123 NOTE: Shaded area is ACCA (TVA) conditions 27.7 0.54 15 1.95 9.3 287 128 30.0 0.56 15 2.01 9.5 296 132 30.9 0.58 14 2.03 9.6 299 134 27.7 0.40 11 1.93 9.2 284 127 30.1 0.42 11 1.99 9.5 293 131 24.4 0.75 18 2.15 10.3 352 128 26.4 0.57 15 2.24 10.6 371 140 28.6 0.59 15 2.31 10.8 383 144 29.4 0.62 14 2.33 10.9 387 146 27.2 0.81 17 2.24 10.6 366 134 26.4 0.78 18 2.22 10.5 363 132 26.4 0.43 11 2.22 10.5 368 139 28.6 0.44 11 2.28 10.7 379 143 24.1 0.62 15 2.13 10.2 348 127 26.1 0.64 15 2.20 10.4 359 131 28.3 0.36 10 2.33 10.9 387 149 30.7 0.38 10 2.40 11.2 399 154 31.6 0.40 10 2.42 11.2 403 155 - - 22.5 0.87 20 2.20 10.6 368 126 24.3 0.90 19 2.27 10.9 379 130 25.1 0.95 18 2.29 10.9 383 132 22.1 0.77 17 2.18 10.5 364 125 23.9 0.79 17 2.25 10.8 375 129 23.1 0.78 18 2.26 10.8 396 134 25.1 0.81 18 2.33 11.1 408 139 25.8 0.85 17 2.36 11.2 412 140 22.9 0.64 15 2.24 10.7 392 133 24.8 0.66 14 2.31 11.0 404 137 25.0 0.59 15 2.35 11.1 418 147 27.1 0.61 15 2.42 11.4 431 151 28.0 0.64 14 2.45 11.5 435 153 25.1 0.44 11 2.33 11.0 414 145 27.2 0.46 11 2.40 11.3 426 150 Design Subcooling, 7 °F @ the liquid access fitting connection AHRI 95 test conditions. Design Superheat 5°F @ the compressor suction access fitting connection. Outdoor Ambient Temperature 65 75 85 95 105 Entering Indoor Wet Bulb Temperature IDB* Airflow 59 63 67 71 59 63 67 71 59 63 67 71 59 63 67 71 59 63 67 MBh 27.9 28.9 31.7 27.3 28.3 31.0 26.6 27.6 30.2 26.0 26.9 29.5 24.7 25.6 28.0 S/T 0.73 0.61 0.42 0.76 0.63 0.44 0.78 0.65 0.45 0.80 0.67 0.46 0.83 0.69 0.48 Delta T 16 14 10 16 14 11 16 14 11 16 14 11 16 14 10 1181 KW 1.72 1.76 1.83 1.89 1.94 2.01 2.03 2.09 2.17 2.16 2.22 2.31 2.27 2.33 2.42 AMPS 8.5 8.7 8.9 9.1 9.3 9.5 9.7 9.9 10.2 10.3 10.5 10.8 10.9 11.1 11.4 HI PR 232 249 263 260 280 296 296 318 336 337 363 383 379 408 431 LO PR 108 115 125 114 121 132 118 126 137 124 132 144 130 139 151 26.9 0.38 10 2.45 11.5 436 156 29.1 0.39 10 2.52 11.8 449 161 30.0 0.41 10 2.55 11.9 454 163 - - 71 - 20.8 0.88 18 2.30 11.1 406 131 22.6 0.91 18 2.37 11.4 419 135 23.2 0.95 17 2.39 11.5 423 136 20.5 0.77 16 2.27 11.0 402 129 22.2 0.80 16 2.34 11.3 415 133 59 22.8 0.84 15 2.37 11.4 419 135 21.4 0.78 17 2.36 11.4 437 139 23.2 0.81 17 2.43 11.6 451 143 23.9 0.85 16 2.45 11.7 455 145 21.2 0.64 14 2.33 11.3 433 138 23.0 0.67 13 2.41 11.6 446 142 63 23.7 0.70 13 2.43 11.6 451 143 23.2 0.59 14 2.45 11.7 462 152 25.1 0.62 14 2.53 12.0 476 157 25.9 0.65 13 2.55 12.1 481 158 23.2 0.45 10 2.43 11.6 457 150 25.2 0.46 10 2.50 11.9 471 155 67 25.9 0.49 10 2.52 12.0 476 157 115 24.9 0.38 10 2.55 12.1 482 162 27.0 0.40 9 2.63 12.4 496 167 27.8 0.42 9 2.65 12.5 501 168 - - 71 - COOLING OPERATION COOLING PERFORMANCE DATA GPC1530M41* MODEL: GPC1530M41 EXPANDED PERFORMANCE DATA 25.9 0.84 22 1.68 8.4 227 106 29.4 0.96 22 1.77 8.7 239 111 28.5 0.91 23 1.75 8.7 237 110 26.3 0.88 23 1.70 8.5 229 107 MBh S/T Delta T KW AMPS HI PR LO PR MBh S/T Delta T KW AMPS HI PR LO PR MBh S/T Delta T KW AMPS HI PR LO PR MBh S/T Delta T KW AMPS HI PR LO PR 1050 919 1181 1050 919 26.8 0.85 23 1.75 8.6 247 114 29.1 0.88 22 1.80 8.8 255 117 30.0 0.92 21 1.82 8.9 257 118 26.4 0.79 21 1.73 8.6 244 112 28.7 0.81 20 1.78 8.8 252 116 28.1 0.76 22 1.82 8.9 261 124 30.5 0.79 21 1.87 9.1 269 128 31.4 0.83 20 1.89 9.1 271 129 28.3 0.64 18 1.80 8.8 258 123 30.6 0.66 18 1.85 9.0 266 126 30.0 0.62 19 1.89 9.1 272 132 32.5 0.64 18 1.95 9.3 280 136 33.5 0.67 18 1.97 9.4 283 137 30.2 0.48 14 1.87 9.1 269 131 32.7 0.50 14 1.93 9.3 278 135 25.7 0.91 23 1.87 9.0 257 113 27.9 0.94 23 1.92 9.2 265 116 28.7 0.99 22 1.94 9.3 268 117 25.3 0.87 22 1.85 9.0 255 112 27.4 0.90 22 1.90 9.2 263 115 26.2 0.88 23 1.92 9.2 277 120 28.4 0.91 23 1.97 9.4 286 124 29.3 0.96 22 1.99 9.5 288 125 25.8 0.81 21 1.90 9.1 274 119 28.0 0.84 21 1.96 9.3 283 122 27.5 0.79 22 1.99 9.5 293 131 29.8 0.82 21 2.05 9.7 302 135 30.6 0.86 21 2.07 9.7 305 136 27.6 0.66 18 1.97 9.4 290 130 29.9 0.69 18 2.03 9.6 299 134 29.3 0.64 19 2.07 9.7 305 139 31.7 0.67 19 2.13 10.0 315 144 32.7 0.70 18 2.16 10.1 318 145 29.5 0.50 15 2.05 9.7 302 138 32.0 0.51 14 2.11 9.9 311 142 25.1 0.93 23 2.01 9.7 293 117 27.2 0.97 23 2.07 9.9 302 121 28.0 1.00 22 2.09 10.0 305 122 24.7 0.89 22 1.99 9.6 290 116 26.7 0.92 22 2.05 9.8 299 120 25.6 0.90 23 2.06 9.9 315 125 27.7 0.93 23 2.13 10.1 325 129 28.6 0.98 22 2.15 10.2 328 130 25.2 0.83 21 2.04 9.8 312 123 NOTE: 27.3 0.87 21 2.11 10.0 322 127 31.2 0.53 14 2.28 10.6 354 148 26.1 0.95 22 2.18 10.4 340 126 26.7 0.89 21 2.24 10.6 366 134 28.5 0.73 18 2.33 10.9 387 146 30.4 0.54 14 2.42 11.2 403 155 26.8 0.81 22 2.15 10.1 333 136 29.0 0.84 21 2.21 10.4 343 140 29.9 0.88 21 2.23 10.5 346 142 28.6 0.66 19 2.23 10.5 347 145 31.0 0.68 19 2.30 10.7 358 149 31.9 0.72 18 2.32 10.8 361 151 24.5 0.96 24 2.14 10.2 333 123 26.5 1.00 23 2.21 10.5 344 127 27.3 1.00 21 2.23 10.5 347 128 25.0 0.93 23 2.20 10.4 359 131 27.1 0.96 23 2.26 10.7 370 135 27.9 1.00 22 2.29 10.8 374 136 26.2 0.84 22 2.28 10.7 379 143 28.3 0.87 22 2.35 11.0 391 147 29.2 0.91 21 2.38 11.1 395 149 23.3 1.00 23 2.25 10.8 375 129 25.2 1.00 22 2.32 11.0 387 133 26.0 1.00 20 2.34 11.1 391 134 22.9 0.95 22 2.23 10.7 371 128 24.8 0.99 21 2.29 10.9 383 132 23.7 0.96 23 2.31 11.0 404 137 25.7 1.00 23 2.38 11.3 416 141 26.5 1.00 21 2.40 11.4 420 143 23.4 0.89 21 2.29 10.9 400 136 25.3 0.93 21 2.36 11.2 412 140 24.8 0.87 22 2.40 11.3 426 150 26.9 0.90 21 2.47 11.6 440 154 27.7 0.95 20 2.50 11.7 444 156 25.0 0.73 18 2.38 11.2 422 148 27.1 0.76 18 2.45 11.5 435 153 26.5 0.71 19 2.49 11.7 445 160 28.7 0.73 18 2.57 12.0 458 164 29.6 0.77 18 2.60 12.1 463 166 26.7 0.54 15 2.47 11.6 440 158 28.9 0.56 14 2.55 11.9 454 163 71 29.8 0.59 14 2.57 12.0 458 164 21.6 1.00 22 2.34 11.3 415 133 23.4 1.00 20 2.41 11.6 427 138 24.1 1.00 19 2.44 11.7 432 139 21.2 0.96 20 2.32 11.2 410 132 23.0 1.00 20 2.39 11.5 423 136 59 23.6 1.00 18 2.41 11.6 427 138 22.0 0.97 21 2.40 11.6 446 142 23.8 1.00 21 2.48 11.8 460 146 24.5 1.00 19 2.50 11.9 464 148 21.7 0.90 20 2.38 11.5 442 141 23.5 0.94 19 2.45 11.7 455 145 63 24.2 1.00 19 2.48 11.8 460 146 23.0 0.88 20 2.50 11.9 471 155 24.9 0.91 20 2.58 12.2 486 160 25.7 0.95 19 2.60 12.3 490 161 23.1 0.73 17 2.47 11.8 466 153 25.1 0.76 17 2.55 12.1 481 158 67 25.8 0.80 16 2.58 12.2 486 160 115 24.6 0.71 18 2.60 12.3 491 165 26.6 0.74 17 2.68 12.6 506 170 27.4 0.77 17 2.71 12.7 512 172 24.7 0.55 14 2.57 12.2 486 163 26.8 0.57 13 2.65 12.5 501 168 71 27.6 0.60 13 2.68 12.6 506 170 COOLING OPERATION KW = Total system power AMPS: Unit amps (comp.+ evaporator + condenser fan motors) 27.9 0.68 19 2.37 11.1 395 152 30.2 0.71 19 2.45 11.3 407 157 31.1 0.74 18 2.47 11.4 412 159 26.9 28.8 24.1 24.6 26.3 28.1 0.68 0.51 0.92 0.86 0.70 0.52 18 15 22 21 18 15 2.12 2.21 2.12 2.17 2.26 2.35 10.1 10.4 10.1 10.3 10.6 11.0 329 344 330 355 375 391 135 143 122 130 142 151 Shaded area reflects AHRI rating conditions 29.2 0.70 18 2.19 10.3 340 139 * Entering Indoor Dry Bulb Temperature NOTE: Shaded area is AHRI Rating Conditions High and low pressures are measured at the liquid and suction access fittings. 85 80 28.0 0.87 21 1.74 8.6 234 109 MBh S/T Delta T KW AMPS HI PR LO PR Design Subcooling, 7 °F @ the liquid access fitting connection AHRI 95 test conditions. Design Superheat 5°F @ the compressor suction access fitting connection. Outdoor Ambient Temperature 65 75 85 95 105 Entering Indoor Wet Bulb Temperature IDB* Airflow 59 63 67 71 59 63 67 71 59 63 67 71 59 63 67 71 59 63 67 MBh 28.9 29.5 31.5 33.7 28.2 28.8 30.8 32.9 27.5 28.1 30.1 32.1 26.9 27.5 29.3 31.4 25.5 26.1 27.9 S/T 0.91 0.85 0.70 0.52 0.94 0.89 0.72 0.54 0.97 0.91 0.74 0.55 1.00 0.94 0.76 0.57 1.00 1.00 0.79 Delta T 20 20 17 14 21 20 17 14 21 20 17 14 21 20 17 14 20 20 17 1181 KW 1.75 1.80 1.87 1.95 1.92 1.97 2.05 2.13 2.07 2.13 2.21 2.30 2.21 2.26 2.35 2.45 2.32 2.38 2.47 AMPS 8.7 8.8 9.1 9.3 9.2 9.4 9.7 10.0 9.9 10.1 10.4 10.7 10.5 10.7 11.0 11.3 11.0 11.3 11.6 HI PR 237 255 269 280 265 286 302 315 302 325 343 358 344 370 391 407 387 416 440 LO PR 110 117 128 136 116 124 135 144 121 129 140 149 127 135 147 157 133 141 154 COOLING PERFORMANCE DATA GPC1530M41* 15 16 MODEL: GPC1536M41 EXPANDED PERFORMANCE DATA 35.1 0.78 22 2.20 10.8 237 109 32.4 0.75 22 2.14 10.6 230 106 MBh S/T Delta T KW AMPS HI PR LO PR MBh S/T Delta T KW AMPS HI PR LO PR 1294 1006 1150 36.2 0.81 21 2.22 10.9 239 110 MBh S/T Delta T KW AMPS HI PR LO PR 1006 36.2 0.69 20 2.26 11.0 255 116 33.4 0.67 20 2.19 10.8 247 113 37.3 0.73 19 2.28 11.1 258 117 33.1 0.55 17 2.17 10.7 245 112 39.2 0.53 16 2.35 11.3 269 127 36.2 0.51 17 2.28 11.1 261 123 40.3 0.55 16 2.37 11.4 272 128 36.2 0.38 13 2.26 11.0 259 122 42.0 0.34 11 2.44 11.6 281 135 38.8 0.33 12 2.37 11.4 272 131 43.3 0.35 11 2.46 11.7 284 137 - 34.3 0.81 22 2.41 11.5 266 116 31.7 0.78 22 2.34 11.2 258 112 35.4 0.84 21 2.44 11.6 269 117 31.2 0.68 19 2.32 11.2 255 111 35.3 0.72 20 2.48 11.7 286 123 32.6 0.69 21 2.40 11.5 278 119 36.4 0.76 20 2.50 11.8 289 124 32.3 0.57 17 2.38 11.4 275 118 * IDB: Entering Indoor Dry Bulb Temperature High and low pressures are measured at the liquid and suction access fittings. 75 31.9 0.66 19 2.11 10.5 228 105 MBh S/T Delta T KW AMPS HI PR LO PR 41.1 0.35 12 2.67 12.4 315 143 37.9 0.34 12 2.60 12.1 306 139 42.3 0.37 11 2.70 12.5 318 144 - 33.5 0.83 22 2.60 12.3 302 120 30.9 0.80 22 2.52 12.0 293 116 34.5 0.87 21 2.62 12.4 305 121 30.4 0.70 19 2.50 12.0 290 115 34.5 0.74 20 2.67 12.6 325 128 31.8 0.71 21 2.59 12.3 316 124 35.5 0.77 20 2.69 12.7 329 129 31.5 0.58 17 2.56 12.2 312 123 37.3 0.56 17 2.77 12.9 344 139 34.5 0.54 17 2.69 12.6 333 135 38.5 0.59 16 2.80 13.0 347 141 34.5 0.41 13 2.66 12.5 330 134 40.1 0.36 12 2.88 13.3 358 149 37.0 0.35 12 2.80 13.0 348 144 41.3 0.38 11 2.91 13.4 362 150 - 32.7 0.85 22 2.76 13.0 344 126 30.2 0.82 23 2.68 12.7 334 122 33.7 0.89 21 2.79 13.1 348 127 29.7 0.72 20 2.65 12.6 331 121 NOTE: Shaded area is ACCA (TVA) conditions 38.3 0.54 17 2.57 12.1 302 134 35.3 0.53 17 2.50 11.8 293 130 39.4 0.57 16 2.60 12.1 305 136 35.4 0.40 13 2.47 11.7 290 129 36.4 0.58 17 2.95 13.7 391 146 33.6 0.56 17 2.86 13.4 380 142 37.5 0.60 16 2.98 13.8 395 148 34.7 0.80 20 2.86 13.4 374 136 33.7 0.76 21 2.84 13.3 371 134 31.1 0.73 21 2.75 13.0 359 130 33.7 0.42 13 2.83 13.3 376 141 30.8 0.60 17 2.72 12.9 356 129 39.1 0.37 12 3.06 14.1 408 156 36.1 0.36 12 2.97 13.8 396 151 40.3 0.39 11 3.09 14.2 412 158 - 31.1 0.88 22 2.90 13.7 387 132 28.7 0.85 22 2.82 13.4 376 128 32.0 0.93 21 2.93 13.9 391 133 28.2 0.75 19 2.79 13.3 372 127 32.0 0.79 20 2.98 14.0 417 141 29.5 0.76 21 2.89 13.7 404 136 32.9 0.83 19 3.01 14.1 421 142 29.2 0.63 17 2.86 13.6 400 135 34.6 0.60 17 3.10 14.4 440 154 31.9 0.58 17 3.00 14.1 427 149 35.7 0.63 16 3.13 14.6 445 155 32.0 0.43 13 2.97 14.0 423 147 Design Subcooling, 7 °F @ the liquid access fitting connection AHRI 95 test conditions. Design Superheat 5°F @ the compressor suction access fitting connection. Outdoor Ambient Temperature 65 75 85 95 105 Entering Indoor Wet Bulb Temperature IDB* Airflow 59 63 67 71 59 63 67 71 59 63 67 71 59 63 67 71 59 63 67 MBh 35.6 36.9 40.4 34.8 36.0 39.5 33.9 35.2 38.5 33.1 34.3 37.6 31.5 32.6 35.7 S/T 0.72 0.60 0.41 0.74 0.62 0.43 0.76 0.64 0.44 0.79 0.66 0.45 0.82 0.68 0.47 Delta T 18 16 12 18 16 12 18 16 12 18 16 12 18 16 12 1294 KW 2.20 2.26 2.35 2.41 2.48 2.57 2.60 2.67 2.77 2.76 2.83 2.95 2.90 2.98 3.09 AMPS 10.8 11.0 11.3 11.5 11.7 12.1 12.3 12.6 12.9 13.0 13.3 13.7 13.7 14.0 14.4 HI PR 237 255 269 266 286 302 302 325 344 344 371 391 387 417 440 LO PR 109 116 127 115 123 134 120 128 139 126 134 146 132 141 153 MBh 34.6 35.8 39.2 33.8 35.0 38.3 33.0 34.2 37.4 32.1 33.3 36.5 30.5 31.7 34.7 S/T 0.68 0.57 0.40 0.71 0.59 0.41 0.73 0.61 0.42 0.75 0.63 0.43 0.78 0.65 0.45 Delta T 19 16 12 19 17 13 19 17 13 19 17 13 19 16 12 70 1150 KW 2.18 2.24 2.32 2.39 2.45 2.55 2.57 2.64 2.74 2.73 2.81 2.92 2.87 2.95 3.06 AMPS 10.7 10.9 11.2 11.4 11.6 12.0 12.2 12.5 12.8 12.9 13.2 13.6 13.6 13.9 14.3 HI PR 235 252 267 263 283 299 299 322 340 341 367 387 384 413 436 LO PR 108 115 126 114 122 133 119 126 138 125 133 145 131 139 152 37.1 0.39 11 3.22 14.9 459 163 34.3 0.37 12 3.12 14.5 445 159 38.3 0.40 11 3.25 15.0 464 165 - 71 - 28.8 0.89 21 3.02 14.4 428 137 26.6 0.86 21 2.93 14.1 415 133 29.6 0.94 20 3.05 14.6 432 138 26.1 0.76 18 2.90 14.0 411 131 59 29.1 0.82 17 3.02 14.4 428 137 28.3 0.78 18 2.99 14.3 424 135 29.6 0.80 19 3.10 14.7 461 145 27.3 0.77 19 3.01 14.4 447 141 30.5 0.84 18 3.13 14.9 465 147 27.1 0.63 16 2.98 14.3 442 140 63 30.2 0.69 15 3.10 14.7 461 145 29.3 0.66 15 3.07 14.6 456 144 32.1 0.60 15 3.22 15.2 486 159 29.6 0.58 16 3.13 14.8 472 154 33.0 0.63 15 3.26 15.3 491 160 29.7 0.44 12 3.10 14.7 467 152 67 33.1 0.48 11 3.22 15.2 486 159 32.1 0.45 12 3.19 15.1 482 157 115 34.4 0.39 11 3.35 15.7 507 169 31.8 0.37 11 3.25 15.3 492 164 35.4 0.41 10 3.39 15.8 512 171 - 71 - COOLING OPERATION COOLING PERFORMANCE DATA GPC1536M41* MODEL: GPC1536M41 EXPANDED PERFORMANCE DATA 33.0 0.82 25 2.16 10.6 232 107 37.5 0.94 25 2.27 11.0 244 113 36.4 0.89 26 2.25 11.0 242 112 33.6 0.86 26 2.18 10.7 234 108 MBh S/T Delta T KW AMPS HI PR LO PR MBh S/T Delta T KW AMPS HI PR LO PR MBh S/T Delta T KW AMPS HI PR LO PR MBh S/T Delta T KW AMPS HI PR LO PR 1150 1006 1294 1150 1006 34.2 0.83 26 2.24 10.9 252 115 37.1 0.86 26 2.30 11.2 260 119 38.2 0.90 25 2.33 11.3 263 120 33.7 0.77 24 2.21 10.8 250 114 36.6 0.80 23 2.28 11.1 258 117 35.9 0.75 25 2.32 11.2 266 126 38.9 0.78 24 2.39 11.5 275 130 40.0 0.82 23 2.42 11.6 277 131 36.0 0.63 21 2.30 11.1 264 124 39.0 0.65 20 2.37 11.4 272 128 38.3 0.61 21 2.42 11.6 278 134 41.5 0.63 21 2.49 11.8 286 138 42.7 0.66 20 2.51 11.9 289 139 38.5 0.47 17 2.39 11.5 275 133 41.7 0.49 16 2.46 11.7 284 137 32.8 0.89 27 2.39 11.4 263 114 35.5 0.93 26 2.46 11.7 271 118 36.6 0.97 25 2.48 11.8 274 119 32.2 0.85 25 2.36 11.3 260 113 34.9 0.88 25 2.44 11.6 269 117 33.4 0.86 26 2.45 11.6 283 122 36.2 0.89 26 2.53 11.9 292 125 37.3 0.94 25 2.55 12.0 295 127 33.0 0.80 24 2.43 11.6 280 120 35.7 0.83 24 2.50 11.8 289 124 35.0 0.78 25 2.55 12.0 299 133 38.0 0.81 24 2.62 12.2 308 137 39.1 0.85 23 2.65 12.3 311 138 35.2 0.65 21 2.52 11.9 296 131 38.1 0.67 21 2.60 12.1 305 136 37.4 0.63 22 2.65 12.3 312 141 40.5 0.65 21 2.73 12.6 321 146 41.7 0.69 20 2.76 12.7 325 147 37.6 0.49 17 2.62 12.2 309 140 40.8 0.50 16 2.70 12.5 318 144 32.0 0.92 27 2.57 12.2 299 119 34.7 0.95 26 2.65 12.5 308 122 35.7 1.00 25 2.68 12.6 312 124 31.5 0.87 25 2.55 12.1 296 118 34.1 0.91 25 2.62 12.4 305 121 32.6 0.88 26 2.64 12.5 322 126 35.4 0.92 26 2.72 12.8 332 130 36.4 0.96 25 2.75 12.9 335 132 32.2 0.82 24 2.61 12.4 319 125 NOTE: 34.9 0.85 24 2.69 12.7 329 129 39.8 0.52 16 2.91 13.4 362 150 33.3 0.93 25 2.79 13.1 348 127 34.0 0.88 24 2.86 13.4 374 136 36.3 0.71 21 2.98 13.8 395 148 38.8 0.53 17 3.09 14.2 412 158 34.2 0.80 25 2.74 12.8 340 138 37.0 0.83 24 2.83 13.1 351 142 38.2 0.87 24 2.85 13.2 354 144 36.5 0.65 22 2.85 13.2 355 147 39.5 0.67 21 2.94 13.5 366 152 40.7 0.70 20 2.97 13.7 369 153 31.2 0.94 27 2.73 12.9 341 125 33.9 0.98 27 2.82 13.2 351 129 34.9 1.00 25 2.85 13.3 355 130 31.9 0.91 27 2.81 13.2 367 133 34.5 0.95 26 2.89 13.5 378 137 35.5 0.99 25 2.92 13.6 382 138 33.4 0.82 25 2.92 13.6 387 145 36.1 0.85 25 3.01 13.9 399 149 37.2 0.89 24 3.04 14.0 403 151 29.7 0.98 27 2.87 13.6 383 131 32.2 1.00 26 2.96 14.0 395 135 33.1 1.00 24 2.99 14.1 399 136 29.2 0.94 25 2.84 13.5 380 129 31.6 0.97 25 2.93 13.9 391 133 30.3 0.95 26 2.95 13.9 413 139 32.8 0.98 26 3.04 14.3 425 143 33.8 1.00 24 3.07 14.4 430 145 29.8 0.88 24 2.92 13.8 409 138 32.3 0.91 23 3.01 14.1 421 142 31.7 0.85 25 3.06 14.3 436 152 34.3 0.89 24 3.16 14.7 449 157 35.4 0.93 23 3.19 14.8 454 158 31.9 0.71 21 3.03 14.2 431 150 34.5 0.74 20 3.13 14.6 445 155 33.8 0.69 21 3.19 14.8 454 162 36.6 0.72 21 3.28 15.1 468 167 37.7 0.75 20 3.32 15.3 473 168 34.0 0.53 17 3.15 14.7 450 160 36.9 0.55 16 3.25 15.0 464 165 71 38.0 0.58 16 3.28 15.1 468 167 27.5 0.99 25 2.99 14.3 424 135 29.8 1.00 24 3.08 14.7 437 139 30.7 1.00 22 3.11 14.8 441 141 27.0 0.94 23 2.96 14.2 419 134 29.3 0.98 23 3.05 14.6 432 138 59 30.2 1.00 21 3.08 14.7 437 139 28.0 0.95 24 3.07 14.6 456 144 30.4 0.99 24 3.16 15.0 470 148 31.3 1.00 22 3.20 15.1 475 150 27.6 0.88 22 3.04 14.5 451 142 29.9 0.92 22 3.13 14.9 465 147 63 30.8 0.96 21 3.16 15.0 470 148 29.4 0.86 23 3.19 15.1 481 157 31.8 0.89 23 3.29 15.4 496 162 32.8 0.94 22 3.32 15.6 501 164 29.5 0.72 19 3.16 14.9 477 156 32.0 0.75 19 3.26 15.3 491 160 67 32.9 0.78 18 3.29 15.4 496 162 115 31.3 0.70 20 3.32 15.5 502 167 33.9 0.72 20 3.42 15.9 518 173 35.0 0.76 19 3.45 16.1 523 174 31.5 0.54 16 3.28 15.4 497 166 34.2 0.56 15 3.39 15.8 512 171 71 35.2 0.59 15 3.42 15.9 518 173 COOLING OPERATION KW = Total system power AMPS: Unit amps (comp.+ evaporator + condenser fan motors) 35.6 0.67 22 3.03 14.0 404 154 38.6 0.69 21 3.12 14.3 416 159 39.7 0.73 20 3.16 14.5 421 161 34.4 36.7 30.7 31.4 33.5 35.8 0.67 0.50 0.90 0.85 0.69 0.51 21 17 25 24 21 17 2.72 2.82 2.71 2.78 2.89 3.00 12.7 13.1 12.8 13.1 13.5 13.9 337 351 337 363 383 400 137 146 124 131 144 153 Shaded area reflects AHRI rating conditions 37.2 0.69 21 2.80 13.0 347 141 * Entering Indoor Dry Bulb Temperature NOTE: Shaded area is AHRI Rating Conditions High and low pressures are measured at the liquid and suction access fittings. 85 80 35.8 0.85 24 2.22 10.9 239 110 MBh S/T Delta T KW AMPS HI PR LO PR Design Subcooling, 7 °F @ the liquid access fitting connection AHRI 95 test conditions. Design Superheat 5°F @ the compressor suction access fitting connection. Outdoor Ambient Temperature 65 75 85 95 105 Entering Indoor Wet Bulb Temperature IDB* Airflow 59 63 67 71 59 63 67 71 59 63 67 71 59 63 67 71 59 63 67 MBh 36.8 37.6 40.2 43.0 36.0 36.8 39.3 42.0 35.1 35.9 38.4 41.0 34.3 35.0 37.4 40.0 32.6 33.3 35.5 S/T 0.89 0.84 0.68 0.51 0.93 0.87 0.71 0.53 0.95 0.89 0.72 0.54 1.00 0.92 0.75 0.56 1.00 0.95 0.78 Delta T 23 22 19 16 24 23 20 16 24 23 20 16 24 23 20 16 23 23 20 1294 KW 2.25 2.30 2.39 2.49 2.46 2.53 2.62 2.73 2.65 2.72 2.83 2.94 2.82 2.89 3.01 3.12 2.96 3.04 3.16 AMPS 11.0 11.2 11.5 11.8 11.7 11.9 12.2 12.6 12.5 12.8 13.1 13.5 13.2 13.5 13.9 14.3 14.0 14.3 14.7 HI PR 242 260 275 286 271 292 308 321 308 332 351 366 351 378 399 416 395 425 449 LO PR 112 119 130 138 118 125 137 146 122 130 142 152 129 137 149 159 135 143 157 COOLING PERFORMANCE DATA GPC1536M41* 17 18 MODEL: GPC1542M41 EXPANDED PERFORMANCE DATA 36.9 0.67 19 2.39 11.8 229 108 41.9 0.83 21 2.51 12.2 241 113 40.7 0.79 22 2.49 12.1 239 112 37.5 0.77 22 2.42 11.9 232 109 MBh S/T Delta T KW AMPS HI PR LO PR MBh S/T Delta T KW AMPS HI PR LO PR MBh S/T Delta T KW AMPS HI PR LO PR MBh S/T Delta T KW AMPS HI PR LO PR 1350 1181 1519 1350 1181 38.7 0.68 21 2.48 12.1 249 116 41.9 0.71 20 2.56 12.4 257 119 43.1 0.74 19 2.58 12.5 260 120 38.3 0.56 17 2.46 12.0 247 114 41.5 0.58 16 2.53 12.3 254 118 41.8 0.52 17 2.58 12.4 263 126 45.3 0.54 17 2.66 12.7 271 130 46.7 0.56 16 2.68 12.8 274 131 41.9 0.39 13 2.55 12.3 261 125 45.4 0.40 12 2.63 12.6 269 129 44.9 0.33 12 2.68 12.8 275 134 48.7 0.35 11 2.76 13.1 283 138 50.1 0.36 11 2.79 13.2 286 140 - - 36.7 0.79 23 2.65 12.6 260 115 39.7 0.82 22 2.73 12.9 268 118 40.9 0.86 21 2.76 13.0 271 119 36.1 0.70 20 2.62 12.5 257 114 39.1 0.72 19 2.70 12.8 265 117 37.8 0.71 21 2.72 12.9 280 122 40.9 0.74 21 2.80 13.2 288 126 42.1 0.77 20 2.83 13.3 291 127 37.4 0.58 17 2.69 12.8 277 121 40.5 0.60 17 2.77 13.1 286 125 * IDB: Entering Indoor Dry Bulb Temperature High and low pressures are measured at the liquid and suction access fittings. 75 70 40.0 0.70 19 2.47 12.0 236 111 MBh S/T Delta T KW AMPS HI PR LO PR 43.9 0.35 12 2.94 13.7 308 142 47.5 0.36 12 3.03 14.0 318 146 48.9 0.38 11 3.06 14.1 321 148 - - 35.8 0.81 23 2.85 13.6 296 119 38.8 0.84 22 2.94 13.9 305 123 39.9 0.88 21 2.97 14.0 308 124 35.2 0.72 20 2.82 13.4 293 118 38.1 0.74 19 2.91 13.8 302 122 36.9 0.73 21 2.93 13.8 318 127 39.9 0.75 21 3.02 14.2 328 131 41.1 0.79 20 3.05 14.3 331 132 36.5 0.60 17 2.90 13.7 315 126 39.5 0.62 17 2.99 14.1 325 129 39.9 0.55 17 3.04 14.2 336 139 43.2 0.57 17 3.14 14.6 346 143 44.5 0.60 16 3.17 14.7 350 144 40.0 0.41 13 3.01 14.1 333 137 43.3 0.43 13 3.10 14.5 343 141 42.8 0.35 12 3.16 14.7 350 148 46.4 0.37 12 3.26 15.0 361 152 47.8 0.39 11 3.29 15.2 365 154 - - 34.9 0.84 23 3.03 14.3 337 125 37.8 0.87 22 3.13 14.7 347 129 39.0 0.91 22 3.16 14.8 351 130 34.3 0.74 20 3.00 14.2 333 124 37.2 0.77 19 3.09 14.6 344 128 NOTE: Shaded area is ACCA (TVA) conditions 40.9 0.54 17 2.82 13.3 295 133 44.3 0.56 17 2.91 13.6 305 137 45.6 0.58 16 2.94 13.7 308 139 41.0 0.40 13 2.80 13.2 292 132 44.4 0.42 13 2.88 13.5 301 136 36.0 0.75 21 3.11 14.6 362 133 38.9 0.57 17 3.23 15.1 383 145 42.2 0.59 17 3.33 15.4 395 150 43.4 0.62 16 3.37 15.6 398 151 40.1 0.82 20 3.24 15.1 377 139 39.0 0.78 21 3.21 15.0 374 137 39.0 0.43 13 3.20 14.9 379 144 42.3 0.44 13 3.30 15.3 391 148 35.6 0.62 17 3.08 14.5 359 132 38.6 0.64 17 3.18 14.9 370 136 41.8 0.37 12 3.36 15.6 399 155 45.3 0.38 12 3.47 15.9 411 160 46.6 0.40 11 3.50 16.1 416 161 - - 33.2 0.87 23 3.19 15.1 379 131 35.9 0.90 22 3.28 15.5 391 135 37.0 0.95 21 3.32 15.6 394 137 32.6 0.77 19 3.15 15.0 375 130 35.3 0.80 19 3.25 15.4 387 134 34.2 0.78 21 3.27 15.4 408 140 37.0 0.81 20 3.37 15.8 420 144 38.1 0.85 20 3.40 16.0 425 145 33.8 0.64 17 3.24 15.3 404 138 36.6 0.66 17 3.34 15.7 416 143 37.0 0.59 17 3.40 15.9 431 152 40.1 0.61 17 3.50 16.3 444 157 41.3 0.64 16 3.54 16.4 448 159 37.1 0.44 13 3.36 15.8 426 151 40.1 0.46 13 3.47 16.2 439 156 Design Subcooling, 7 °F @ the liquid access fitting connection AHRI 95 test conditions. Design Superheat 5°F @ the compressor suction access fitting connection. Outdoor Ambient Temperature 65 75 85 95 105 Entering Indoor Wet Bulb Temperature IDB* Airflow 59 63 67 71 59 63 67 71 59 63 67 71 59 63 67 71 59 63 67 MBh 41.2 42.7 46.8 40.2 41.7 45.7 39.3 40.7 44.6 38.3 39.7 43.5 36.4 37.7 41.3 S/T 0.73 0.61 0.42 0.76 0.63 0.44 0.78 0.65 0.45 0.80 0.67 0.46 0.83 0.70 0.48 Delta T 18 16 12 18 16 12 19 16 12 19 16 12 18 16 12 1519 KW 2.49 2.56 2.66 2.73 2.80 2.91 2.94 3.02 3.13 3.12 3.21 3.33 3.28 3.37 3.50 AMPS 12.1 12.4 12.7 12.9 13.2 13.6 13.9 14.2 14.6 14.7 15.0 15.4 15.5 15.8 16.3 HI PR 239 257 271 268 288 305 305 328 346 347 374 394 390 420 444 LO PR 112 119 130 118 126 137 123 131 143 129 137 150 135 144 157 39.7 0.38 12 3.53 16.4 449 162 43.0 0.39 12 3.64 16.8 463 167 44.3 0.41 11 3.68 17.0 468 169 - - 71 - 30.7 0.88 21 3.32 15.9 419 136 33.3 0.91 21 3.42 16.3 432 140 34.3 0.96 20 3.45 16.4 436 141 30.2 0.77 18 3.28 15.8 414 134 32.7 0.80 18 3.39 16.2 427 139 59 33.7 0.84 17 3.42 16.3 431 140 31.6 0.79 19 3.41 16.2 450 144 34.3 0.82 19 3.51 16.7 464 149 35.3 0.85 18 3.54 16.8 469 150 31.3 0.65 16 3.37 16.1 446 143 33.9 0.67 15 3.47 16.5 460 147 63 35.0 0.70 15 3.51 16.7 464 149 34.3 0.59 16 3.54 16.7 476 158 37.1 0.62 16 3.65 17.1 490 163 38.2 0.65 15 3.68 17.3 495 164 34.3 0.45 12 3.50 16.6 471 156 37.2 0.46 12 3.61 17.0 485 161 67 38.3 0.49 11 3.65 17.1 490 163 115 36.8 0.38 11 3.68 17.3 496 168 39.8 0.40 11 3.79 17.7 511 173 41.0 0.42 10 3.83 17.9 517 175 - - 71 - COOLING OPERATION COOLING PERFORMANCE DATA GPC1542M41* MODEL: GPC1542M41 EXPANDED PERFORMANCE DATA 38.2 0.84 25 2.44 11.9 234 110 43.4 0.96 25 2.56 12.4 246 115 42.1 0.91 26 2.54 12.3 244 114 38.9 0.88 27 2.46 12.0 236 111 MBh S/T Delta T KW AMPS HI PR LO PR MBh S/T Delta T KW AMPS HI PR LO PR MBh S/T Delta T KW AMPS HI PR LO PR MBh S/T Delta T KW AMPS HI PR LO PR 1350 1181 1519 1350 1181 39.6 0.85 26 2.53 12.3 254 118 42.9 0.88 26 2.61 12.6 262 122 44.2 0.92 25 2.63 12.6 265 123 39.0 0.79 24 2.50 12.2 252 117 42.3 0.82 24 2.58 12.5 260 120 41.5 0.77 25 2.63 12.6 269 129 45.0 0.79 24 2.71 12.9 277 133 46.3 0.83 23 2.74 13.0 280 134 41.7 0.64 21 2.60 12.5 266 127 45.2 0.66 20 2.68 12.8 274 131 44.3 0.62 21 2.73 13.0 280 137 48.0 0.64 21 2.82 13.3 289 141 49.4 0.68 20 2.84 13.4 292 143 44.6 0.48 17 2.71 12.9 277 136 48.3 0.50 16 2.79 13.2 286 140 38.0 0.91 27 2.70 12.8 265 117 41.1 0.95 27 2.78 13.1 273 121 42.4 0.99 25 2.81 13.2 276 122 37.3 0.87 25 2.67 12.7 263 116 40.4 0.90 25 2.76 13.0 271 119 38.7 0.88 27 2.77 13.1 285 125 41.9 0.91 26 2.86 13.4 294 128 43.2 0.96 25 2.89 13.5 297 130 38.1 0.82 24 2.74 13.0 283 123 41.3 0.85 24 2.83 13.3 291 127 40.5 0.79 25 2.88 13.5 301 136 43.9 0.82 25 2.97 13.8 311 140 45.2 0.86 24 3.00 13.9 314 142 40.7 0.66 21 2.85 13.4 298 135 44.1 0.69 21 2.94 13.7 308 139 43.3 0.64 22 2.99 13.9 314 145 46.9 0.67 21 3.09 14.2 324 149 48.3 0.70 20 3.12 14.3 327 151 43.6 0.50 17 2.97 13.8 311 143 47.2 0.51 17 3.06 14.1 321 148 37.1 0.94 27 2.91 13.8 302 122 40.2 0.97 27 3.00 14.1 311 125 41.4 1.00 25 3.03 14.2 314 127 36.4 0.89 25 2.88 13.7 299 120 39.5 0.93 25 2.97 14.0 308 124 37.8 0.90 27 2.99 14.1 325 129 40.9 0.94 26 3.08 14.4 335 133 42.2 0.98 25 3.11 14.5 338 135 37.2 0.84 24 2.96 13.9 321 128 NOTE: 40.3 0.87 24 3.05 14.3 331 132 46.1 0.53 17 3.29 15.2 365 154 38.5 0.96 25 3.16 14.8 351 130 39.4 0.90 24 3.24 15.1 377 139 42.0 0.73 21 3.37 15.6 399 152 44.9 0.54 17 3.50 16.1 416 161 39.6 0.81 25 3.10 14.4 343 141 42.9 0.84 25 3.20 14.8 353 146 44.2 0.89 24 3.23 14.9 357 147 42.2 0.66 22 3.23 14.9 358 150 45.7 0.69 21 3.32 15.3 369 155 47.1 0.72 20 3.36 15.4 372 157 36.2 0.97 27 3.09 14.6 344 128 39.2 1.00 27 3.19 14.9 354 132 40.4 1.00 24 3.22 15.0 358 133 36.9 0.93 27 3.17 14.9 370 136 39.9 0.97 26 3.27 15.2 381 140 41.1 1.00 25 3.30 15.4 385 142 38.6 0.84 25 3.30 15.3 390 148 41.8 0.87 25 3.40 15.7 402 153 43.1 0.91 24 3.43 15.8 407 155 34.4 1.00 27 3.25 15.4 387 134 37.2 1.00 25 3.35 15.8 398 138 38.3 1.00 23 3.38 15.9 402 139 33.8 0.96 25 3.22 15.3 383 133 36.6 0.99 25 3.32 15.6 395 137 35.0 0.97 26 3.34 15.7 416 142 37.9 1.00 26 3.44 16.1 429 147 39.1 1.00 24 3.47 16.2 433 148 34.5 0.90 24 3.30 15.6 412 141 37.4 0.93 24 3.40 16.0 425 145 36.7 0.87 25 3.47 16.2 439 156 39.7 0.90 24 3.57 16.6 453 160 40.9 0.95 24 3.61 16.7 457 162 36.9 0.73 21 3.43 16.0 435 154 39.9 0.76 21 3.54 16.4 448 159 39.1 0.71 22 3.60 16.7 458 166 42.4 0.73 21 3.71 17.1 472 171 43.7 0.77 20 3.75 17.3 477 172 39.4 0.55 17 3.57 16.6 454 164 42.7 0.57 16 3.68 17.0 468 169 71 44.0 0.59 16 3.71 17.1 472 171 31.8 1.00 25 3.38 16.2 427 139 34.5 1.00 23 3.49 16.6 440 143 35.5 1.00 21 3.52 16.7 445 144 31.3 0.96 23 3.35 16.0 423 137 33.9 1.00 23 3.45 16.4 436 141 59 34.9 1.00 21 3.49 16.6 440 143 32.4 0.98 25 3.47 16.5 460 147 35.1 1.00 24 3.58 16.9 474 152 36.2 1.00 22 3.62 17.1 479 153 32.0 0.90 22 3.44 16.4 455 146 34.6 0.94 22 3.55 16.8 469 150 63 35.7 1.00 22 3.58 16.9 474 152 34.0 0.88 23 3.61 17.0 485 161 36.8 0.91 23 3.72 17.4 500 166 37.9 0.96 22 3.76 17.6 505 168 34.1 0.74 20 3.57 16.9 480 159 37.0 0.76 19 3.68 17.3 495 164 67 38.1 0.80 18 3.72 17.4 500 166 115 36.3 0.71 20 3.75 17.6 506 171 39.3 0.74 20 3.87 18.0 522 177 40.5 0.78 19 3.91 18.2 527 178 36.5 0.55 16 3.72 17.4 501 170 39.6 0.57 15 3.83 17.9 517 175 71 40.7 0.60 15 3.87 18.0 522 177 COOLING OPERATION KW = Total system power AMPS: Unit amps (comp.+ evaporator + condenser fan motors) 41.2 0.68 22 3.43 15.8 407 158 44.6 0.71 22 3.54 16.2 420 163 46.0 0.74 21 3.57 16.3 424 165 39.8 42.5 35.5 36.3 38.8 41.5 0.68 0.51 0.92 0.86 0.70 0.53 21 17 25 24 21 17 3.07 3.19 3.06 3.14 3.27 3.40 14.3 14.8 14.5 14.8 15.2 15.7 339 354 340 366 387 403 140 149 127 135 147 157 Shaded area reflects AHRI rating conditions 43.1 0.71 21 3.17 14.7 350 144 * Entering Indoor Dry Bulb Temperature NOTE: Shaded area is AHRI Rating Conditions High and low pressures are measured at the liquid and suction access fittings. 85 80 41.4 0.87 25 2.51 12.2 241 113 MBh S/T Delta T KW AMPS HI PR LO PR Design Subcooling, 7 °F @ the liquid access fitting connection AHRI 95 test conditions. Design Superheat 5°F @ the compressor suction access fitting connection. Outdoor Ambient Temperature 65 75 85 95 105 Entering Indoor Wet Bulb Temperature IDB* Airflow 59 63 67 71 59 63 67 71 59 63 67 71 59 63 67 71 59 63 67 MBh 42.6 43.6 46.6 49.8 41.7 42.6 45.5 48.6 40.7 41.5 44.4 47.5 39.7 40.5 43.3 46.3 37.7 38.5 41.1 S/T 0.91 0.86 0.70 0.52 0.95 0.89 0.72 0.54 0.97 0.91 0.74 0.55 1.00 0.94 0.76 0.57 1.00 1.00 0.79 Delta T 24 23 20 16 24 23 20 16 24 23 20 16 24 23 20 16 23 23 20 1519 KW 2.54 2.61 2.71 2.82 2.78 2.86 2.97 3.09 3.00 3.08 3.20 3.32 3.19 3.27 3.40 3.54 3.35 3.44 3.57 AMPS 12.3 12.6 12.9 13.3 13.1 13.4 13.8 14.2 14.1 14.4 14.8 15.3 14.9 15.2 15.7 16.2 15.8 16.1 16.6 HI PR 244 262 277 289 273 294 311 324 311 335 353 369 354 381 402 420 398 429 453 LO PR 114 122 133 141 121 128 140 149 125 133 146 155 132 140 153 163 138 147 160 COOLING PERFORMANCE DATA GPC1542M41* 19 20 MODEL: GPC1548M41 EXPANDED PERFORMANCE DATA 43.4 0.78 23 2.76 12.6 237 109 40.0 0.75 23 2.67 12.3 230 106 MBh S/T Delta T KW AMPS HI PR LO PR MBh S/T Delta T KW AMPS HI PR LO PR 1519 1181 1350 44.7 0.81 22 2.78 12.7 239 110 MBh S/T Delta T KW AMPS HI PR LO PR 1181 44.6 0.69 21 2.83 12.9 255 116 41.2 0.67 21 2.75 12.5 247 112 46.0 0.73 20 2.86 13.0 258 117 40.8 0.55 17 2.72 12.4 245 111 48.3 0.53 17 2.94 13.2 269 127 44.6 0.51 18 2.85 12.9 261 123 49.8 0.55 17 2.97 13.3 272 128 44.7 0.38 13 2.82 12.8 259 122 51.9 0.34 12 3.06 13.7 281 135 47.9 0.33 12 2.97 13.3 273 131 53.4 0.35 11 3.09 13.8 284 136 - 42.4 0.80 23 3.02 13.5 266 115 39.1 0.78 24 2.93 13.2 258 112 43.6 0.84 22 3.05 13.6 269 116 38.4 0.68 20 2.90 13.1 255 111 43.6 0.72 21 3.10 13.8 286 122 40.3 0.69 22 3.01 13.5 278 119 44.9 0.75 21 3.13 13.9 289 124 39.8 0.57 18 2.98 13.3 275 118 47.2 0.54 18 3.23 14.2 302 134 43.6 0.53 18 3.13 13.8 293 130 48.6 0.57 17 3.26 14.3 305 135 43.7 0.39 13 3.10 13.7 290 128 50.7 0.35 12 3.35 14.7 315 142 46.8 0.34 12 3.25 14.3 306 138 52.2 0.37 12 3.39 14.8 318 144 - 41.3 0.83 23 3.26 14.5 302 120 38.2 0.80 24 3.16 14.2 293 116 42.6 0.87 22 3.29 14.7 306 121 37.5 0.70 20 3.13 14.1 290 115 42.6 0.74 21 3.34 14.9 326 127 39.3 0.71 22 3.24 14.5 316 123 43.8 0.77 21 3.38 15.0 329 129 38.9 0.58 18 3.21 14.4 313 122 46.1 0.56 18 3.48 15.3 344 139 42.5 0.54 18 3.37 14.9 333 135 47.5 0.59 17 3.51 15.4 347 140 42.6 0.40 13 3.34 14.8 330 133 - 49.5 0.36 12 3.62 15.8 359 148 45.6 0.35 12 3.51 15.4 348 144 50.9 0.38 12 3.65 16.0 362 149 * Entering Indoor Dry Bulb Temperature NOTE: Shaded area is ACCA (TVA) conditions High and low pressures are measured at the liquid and suction access fittings. 75 39.4 0.66 20 2.65 12.2 228 105 MBh S/T Delta T KW AMPS HI PR LO PR 40.3 0.85 23 3.47 15.4 345 126 37.2 0.82 24 3.36 15.1 334 122 41.5 0.89 22 3.50 15.6 348 127 36.6 0.72 21 3.33 14.9 331 121 45.0 0.58 18 3.70 16.3 391 146 41.5 0.56 18 3.59 15.9 380 142 46.3 0.60 17 3.73 16.4 395 147 42.8 0.80 21 3.59 15.9 374 135 41.5 0.76 22 3.56 15.8 371 134 38.3 0.73 22 3.45 15.4 360 130 41.6 0.42 14 3.55 15.7 376 140 37.9 0.60 18 3.42 15.3 356 128 48.2 0.37 12 3.85 16.8 408 155 44.5 0.36 12 3.73 16.4 396 151 49.7 0.39 12 3.88 17.0 412 157 - 38.3 0.88 23 3.64 16.4 388 132 35.4 0.85 23 3.53 15.9 376 128 39.5 0.93 22 3.68 16.5 391 133 34.8 0.75 20 3.50 15.8 372 126 39.5 0.79 21 3.74 16.7 417 140 36.4 0.76 22 3.63 16.3 405 136 40.6 0.83 20 3.78 16.9 421 142 36.1 0.63 18 3.59 16.2 400 135 42.7 0.60 17 3.89 17.2 440 153 39.4 0.58 18 3.77 16.8 427 148 44.0 0.63 17 3.92 17.4 445 155 39.5 0.43 13 3.73 16.6 423 147 Design Subcooling, 7 °F @ the liquid access fitting connection AHRI 95 test conditions. Design Superheat 5°F @ the compressor suction access fitting connection. Outdoor Ambient Temperature 65 75 85 95 105 Entering Indoor Wet Bulb Temperature IDB* Airflow 59 63 67 71 59 63 67 71 59 63 67 71 59 63 67 71 59 63 67 MBh 43.9 45.5 49.9 42.9 44.5 48.7 41.9 43.4 47.6 40.9 42.3 46.4 38.8 40.2 44.1 S/T 0.72 0.60 0.41 0.74 0.62 0.43 0.76 0.64 0.44 0.79 0.66 0.45 0.82 0.68 0.47 Delta T 19 16 13 19 17 13 19 17 13 19 17 13 19 17 13 1519 KW 2.76 2.83 2.94 3.02 3.10 3.22 3.26 3.34 3.48 3.46 3.56 3.70 3.64 3.74 3.89 AMPS 12.6 12.9 13.2 13.5 13.8 14.2 14.5 14.9 15.3 15.4 15.8 16.3 16.3 16.7 17.2 HI PR 237 255 269 266 286 302 302 325 344 344 371 391 388 417 440 LO PR 109 116 127 115 122 134 120 127 139 126 134 146 132 140 153 MBh 42.6 44.2 48.4 41.6 43.2 47.3 40.7 42.1 46.2 39.7 41.1 45.0 37.7 39.1 42.8 S/T 0.68 0.57 0.40 0.71 0.59 0.41 0.73 0.61 0.42 0.75 0.63 0.43 0.78 0.65 0.45 Delta T 20 17 13 20 17 13 20 17 13 20 18 13 20 17 13 70 1350 KW 2.73 2.80 2.91 2.99 3.07 3.19 3.22 3.31 3.44 3.43 3.52 3.66 3.60 3.70 3.85 AMPS 12.5 12.8 13.1 13.4 13.7 14.1 14.4 14.7 15.2 15.3 15.7 16.1 16.2 16.6 17.1 HI PR 235 252 267 263 283 299 299 322 340 341 367 388 384 413 436 LO PR 108 115 125 114 121 132 118 126 138 124 132 145 130 139 151 45.8 0.39 12 4.04 17.8 459 163 42.3 0.37 12 3.92 17.4 446 158 47.2 0.40 12 4.08 18.0 464 165 - 71 - 35.5 0.89 22 3.79 17.2 428 136 32.8 0.86 22 3.68 16.8 415 132 36.6 0.93 21 3.83 17.4 433 138 32.2 0.76 19 3.64 16.7 411 131 59 36.0 0.82 18 3.79 17.2 428 136 34.9 0.78 19 3.76 17.1 424 135 36.5 0.80 20 3.89 17.6 461 145 33.7 0.77 20 3.78 17.2 447 141 37.6 0.84 19 3.93 17.8 465 146 33.4 0.63 16 3.74 17.0 442 139 63 37.3 0.69 15 3.89 17.6 461 145 36.2 0.65 16 3.86 17.5 456 143 39.6 0.60 16 4.05 18.2 487 158 36.5 0.58 17 3.93 17.7 472 153 40.7 0.63 16 4.09 18.3 491 160 36.6 0.44 12 3.89 17.6 467 152 67 40.8 0.48 12 4.05 18.2 487 158 39.6 0.45 12 4.01 18.0 482 157 115 42.5 0.39 11 4.21 18.8 508 169 39.2 0.37 11 4.08 18.3 492 163 43.7 0.41 11 4.25 19.0 513 170 - 71 - COOLING OPERATION COOLING PERFORMANCE DATA GPC1548M41* MODEL: GPC1548M41 EXPANDED PERFORMANCE DATA 40.7 0.82 26 2.70 12.4 232 107 46.3 0.94 26 2.84 12.9 244 112 44.9 0.89 27 2.81 12.8 242 111 41.4 0.86 28 2.73 12.5 235 108 MBh S/T Delta T KW AMPS HI PR LO PR MBh S/T Delta T KW AMPS HI PR LO PR MBh S/T Delta T KW AMPS HI PR LO PR MBh S/T Delta T KW AMPS HI PR LO PR 1350 1181 1519 1350 1181 42.3 0.83 27 2.80 12.8 252 115 45.8 0.86 27 2.89 13.1 260 118 47.1 0.90 26 2.92 13.2 263 119 41.6 0.77 25 2.77 12.7 250 114 45.1 0.80 25 2.86 13.0 258 117 44.3 0.75 26 2.91 13.1 267 125 47.9 0.78 25 3.00 13.5 275 129 49.4 0.82 24 3.03 13.6 278 130 44.5 0.63 22 2.88 13.0 264 124 48.2 0.65 21 2.97 13.3 272 128 47.2 0.61 22 3.03 13.6 278 133 51.1 0.63 22 3.12 13.9 287 138 52.7 0.66 21 3.15 14.0 289 139 47.5 0.47 17 3.00 13.4 275 132 51.5 0.49 17 3.09 13.8 284 136 40.5 0.89 28 2.99 13.4 263 114 43.9 0.93 28 3.08 13.7 271 117 45.2 0.97 27 3.11 13.8 274 119 39.8 0.85 26 2.96 13.3 261 113 43.1 0.88 26 3.05 13.6 269 116 41.3 0.86 28 3.07 13.7 283 121 44.7 0.89 27 3.17 14.0 292 125 46.1 0.94 26 3.20 14.1 295 126 40.7 0.80 25 3.04 13.6 280 120 44.1 0.83 25 3.13 13.9 289 124 43.2 0.78 26 3.19 14.1 299 132 46.8 0.81 26 3.29 14.4 308 136 48.2 0.84 25 3.32 14.6 311 138 43.4 0.65 22 3.16 14.0 296 131 47.1 0.67 22 3.26 14.3 305 135 46.1 0.63 23 3.32 14.5 312 141 50.0 0.65 22 3.42 14.9 322 145 51.5 0.69 21 3.46 15.0 325 147 46.4 0.49 18 3.29 14.4 309 140 50.3 0.50 17 3.39 14.8 318 144 39.5 0.91 28 3.22 14.4 299 118 42.8 0.95 28 3.32 14.8 309 122 44.1 0.99 27 3.36 14.9 312 123 38.8 0.87 26 3.19 14.3 296 117 42.1 0.91 26 3.29 14.7 306 121 40.3 0.88 28 3.31 14.7 322 126 43.6 0.92 27 3.41 15.1 332 130 45.0 0.96 26 3.45 15.2 335 131 39.7 0.82 25 3.28 14.6 319 125 NOTE: 43.0 0.85 25 3.38 15.0 329 129 49.1 0.52 17 3.65 16.0 362 149 41.1 0.93 26 3.50 15.6 348 127 42.0 0.88 25 3.59 15.9 374 135 44.8 0.71 22 3.74 16.4 395 147 47.9 0.53 17 3.88 17.0 412 157 42.2 0.80 26 3.44 15.2 340 138 45.7 0.83 26 3.55 15.6 351 142 47.1 0.87 25 3.58 15.7 354 143 45.0 0.65 23 3.58 15.7 355 146 48.8 0.67 22 3.69 16.1 366 151 50.2 0.70 21 3.72 16.2 369 153 38.6 0.94 28 3.43 15.3 341 124 41.8 0.98 28 3.54 15.7 351 128 43.0 1.00 26 3.57 15.8 355 130 39.3 0.91 28 3.52 15.7 367 132 42.6 0.95 27 3.63 16.1 378 136 43.9 0.99 26 3.67 16.2 382 138 41.2 0.82 26 3.66 16.1 387 144 44.6 0.85 26 3.77 16.5 399 149 45.9 0.89 25 3.81 16.7 403 150 36.6 0.98 28 3.60 16.2 384 130 39.7 1.00 27 3.72 16.6 395 134 40.9 1.00 25 3.75 16.8 399 136 36.0 0.93 26 3.57 16.1 380 129 39.0 0.97 26 3.68 16.5 391 133 37.3 0.95 27 3.70 16.6 413 139 40.5 0.98 27 3.81 17.0 426 143 41.7 1.00 25 3.85 17.1 430 144 36.8 0.88 25 3.66 16.4 409 137 39.9 0.91 25 3.78 16.9 421 142 39.1 0.85 26 3.85 17.1 436 151 42.4 0.89 26 3.96 17.5 449 156 43.6 0.93 25 4.00 17.7 454 158 39.3 0.71 22 3.81 16.9 432 150 42.6 0.74 21 3.93 17.4 445 155 41.7 0.69 22 4.00 17.7 455 161 45.2 0.72 22 4.12 18.1 469 166 46.6 0.75 21 4.16 18.3 473 168 42.0 0.53 17 3.96 17.5 450 160 45.5 0.55 17 4.08 18.0 464 165 71 46.9 0.58 16 4.12 18.1 469 166 33.9 0.99 26 3.75 17.1 424 135 36.8 1.00 25 3.87 17.5 437 139 37.9 1.00 23 3.91 17.7 441 140 33.3 0.94 24 3.72 16.9 420 133 36.1 0.98 24 3.83 17.4 433 138 59 37.2 1.00 23 3.87 17.5 437 139 34.6 0.95 26 3.85 17.5 456 143 37.5 0.99 25 3.97 17.9 470 148 38.6 1.00 23 4.01 18.1 475 149 34.1 0.88 23 3.82 17.3 452 142 36.9 0.92 23 3.93 17.8 465 146 63 38.0 0.96 22 3.97 17.9 470 148 36.2 0.86 24 4.01 18.0 482 157 39.2 0.89 24 4.13 18.5 496 161 40.4 0.94 23 4.17 18.7 501 163 36.4 0.72 20 3.97 17.9 477 155 39.4 0.75 20 4.09 18.3 492 160 67 40.6 0.78 19 4.13 18.5 496 161 115 38.6 0.70 21 4.17 18.7 502 167 41.9 0.72 21 4.29 19.2 518 172 43.1 0.76 20 4.34 19.3 523 174 38.9 0.54 16 4.13 18.5 497 165 42.2 0.56 16 4.25 19.0 513 170 71 43.4 0.58 15 4.29 19.2 518 172 COOLING OPERATION KW = Total system power AMPS: Unit amps (comp.+ evaporator + condenser fan motors) 43.9 0.67 23 3.81 16.7 404 154 47.6 0.69 22 3.92 17.1 417 159 49.0 0.73 22 3.96 17.3 421 160 42.4 45.3 37.9 38.7 41.4 44.2 0.67 0.50 0.90 0.84 0.69 0.51 22 18 27 25 22 18 3.41 3.54 3.40 3.49 3.62 3.77 15.1 15.6 15.2 15.5 16.0 16.5 337 351 338 363 384 400 136 145 123 131 143 152 Shaded area reflects AHRI rating conditions 45.9 0.69 22 3.51 15.4 347 140 * Entering Indoor Dry Bulb Temperature NOTE: Shaded area is AHRI Rating Conditions High and low pressures are measured at the liquid and suction access fittings. 85 80 44.1 0.85 26 2.78 12.7 239 110 MBh S/T Delta T KW AMPS HI PR LO PR Design Subcooling, 7 °F @ the liquid access fitting connection AHRI 95 test conditions. Design Superheat 5°F @ the compressor suction access fitting connection. Outdoor Ambient Temperature 65 75 85 95 105 Entering Indoor Wet Bulb Temperature IDB* Airflow 59 63 67 71 59 63 67 71 59 63 67 71 59 63 67 71 59 63 67 MBh 45.5 46.5 49.6 53.1 44.4 45.4 48.5 51.8 43.3 44.3 47.3 50.6 42.3 43.2 46.2 49.4 40.2 41.1 43.9 S/T 0.89 0.84 0.68 0.51 0.93 0.87 0.71 0.53 0.95 0.89 0.72 0.54 1.00 0.92 0.75 0.56 1.00 0.95 0.78 Delta T 25 24 20 16 25 24 21 17 25 24 21 17 26 24 21 17 24 24 21 1519 KW 2.81 2.89 3.00 3.12 3.08 3.17 3.29 3.42 3.32 3.41 3.55 3.69 3.54 3.63 3.77 3.92 3.72 3.81 3.96 AMPS 12.8 13.1 13.5 13.9 13.7 14.0 14.4 14.9 14.8 15.1 15.6 16.1 15.7 16.1 16.5 17.1 16.6 17.0 17.5 HI PR 242 260 275 287 271 292 308 322 309 332 351 366 351 378 399 417 395 426 449 LO PR 111 118 129 138 117 125 136 145 122 130 142 151 128 136 149 159 134 143 156 COOLING PERFORMANCE DATA GPC1548M41* 21 COOLING PERFORMANCE DATA PERFORMANCE TEST All data based upon listed indoor dry bulb temperature. .00 inches external static pressure on coil of outdoor section. Indoor air cubic feet per minute (CFM) as listed in the Performance Data Sheets: If conditions vary from this, results will change as follows: 1. As indoor dry bulb temperatures increase, a slight increase will occur in indoor air temperature drop (Delta T). Low and high side pressures and power will not change. 2. As indoor CFM decreases, a slight increase will occur in indoor temperature drop (Delta T). A slight decrease will occur in low and high side pressures and power. A properly operating unit should be within plus or minus 3 degrees of the typical (Delta T) value shown. A properly operating unit should be within plus or minus 7 PSIG of the HI PR shown. A properly operating unit should be within plus or minus 3 PSIG of the LO PR shown. A properly operating unit should be within plus or minus 3 Amps of the typical value shown. 22 WIRING DIAGRAMS HKR*** BK BK BK BK BK M1 M1 M3 M2 M4 M2 BK BK BK BK BK WARNING HIGH VOLTAGE! DISCONNECT ALL POWER BEFORE SERVICING OR INSTALLING THIS UNIT. MULTIPLE POWER SOURCES MAY BE PRESENT. FAILURE TO DO SO MAY CAUSE PROPERTY DAMAGE, PERSONAL INJURY OR DEATH. BK BK BK BK BK BK BK M1 M3 M1 M2 M4 M2 M1 M3 M5 M7 M2 M4 M6 M8 BK BK BK BK BK Wiring is subject to change. Always refer to the wiring diagram on the unit for the most up-to-date wiring. 23 24 Wiring is subject to change. Always refer to the wiring diagram on the unit for the most up-to-date wiring. GR PU YL EM C L G N 1 2 3 4 5 BL SEE NOTE 2 BK GR GR WH YL BL C F BR RD RD RCCF H YL 24V GR 4 5 2 1 6 3 PLF RD BL 7 8 9 WH NOTE #3 SA (IF USED) SEE NOTE 4 BL 208 240 TR C 3 2 BK 1 PU WARNING BK CM PU BR BK PU BR BR PU YL RD RD BK BK BK RD BL YL RD COMP S C R RD GR T1 T2 T H E R M O S T A T CONTROL BOX ++ W2 C Y R G W1 60 2 0 8 2 4 0 / 1 / 208-240/1/60 0140G01077 REV A HPS BR BL YL RD GR WH GND SEE NOTE 5 LVJB BK BL/PNK BL/PNK L1 C L2 PU HIGH VOLTAGE! DISCONNECT ALL POWER BEFORE SERVICING OR INSTALLING THIS UNIT. MULTIPLE POWER SOURCES MAY BE PRESENT. FAILURE TO DO SO MAY CAUSE PROPERTY DAMAGE, PERSONAL INJURY OR DEATH. WIRING DIAGRAMS GPC15[24-48]M41* L1 1 PLF 6 5 4 N C EM NOTE #2 G C R 2 3 R NOTE #3 S.A. S COMP IF USED T1 F W1 24V 2 Y 208-240 3 CM G HPS C 1 EM C 2 TR 1 C THERMOSTAT W2 3 L RCCF NOTE #4 H C T2 SUPPLY VOLTAGE 208-240/1/60 C SEE NOTE #2 L2 WARNING HIGH PRESSURE SWITCH HPS WIRE CODE BK BLACK BL BLUE BR BROWN GR GREEN OR ORANGE PU PURPLE RD RED WH WHITE YL YELLOW BL/PNK BLUE/PINK STRIPE FIELD WIRING HIGH VOLTAGE LOW VOLTAGE FACTORY WIRING LINE VOLTAGE LOW VOLTAGE OPTIONAL HIGH VOLTAGE 208-240/1/60 0140G01077 REV A SEE UNIT RATING PLATE FOR TYPE AND SIZE OF OVER CURRENT PROTECTION 1. REPLACEMENT WIRE MUST BE SAME SIZE AND TYPE INSULATION AS ORIGINAL (AT LEAST 105°C) USE COPPER CONDUCTOR ONLY. 2. TO CHANGE EVAPORATOR MOTOR SPEED MOVE WHITE AND YELLOW LEADS FROM EM"2" AND "3" TO "4" AND "5". IF BOTH LEADS ARE ENERGIZED, THE HIGHER SPEED SETTING IS USED. 3. FOR 208 VOLT TRANSFORMER OPERATION MOVE PURPLE WIRES FROM TERMINAL 3 TO TERMINAL 2 ON TRANSFORMER. 4. START ASSIST FACTOR EQUIPPED WHEN REQUIRED. 5. USE COPPER CONDUCTORS ONLY. ++ USE N.E.C. CLASS 2 WIRE NOTES: SA TR CONTACTOR CONDENSER MOTOR COMPRESSOR EVAPORATOR MOTOR EQUIPMENT GROUND LOW VOLTAGE JUNCTION BOX FEMALE PLUG / CONNECTOR RUN CAPACITOR FOR COMPRESSOR AND FAN START ASSIST TRANSFORMER C CM COMP EM GND LVJB PLF RCCF COMPONENT LEGEND HIGH VOLTAGE! DISCONNECT ALL POWER BEFORE SERVICING OR INSTALLING THIS UNIT. MULTIPLE POWER SOURCES MAY BE PRESENT. FAILURE TO DO SO MAY CAUSE PROPERTY DAMAGE, PERSONAL INJURY OR DEATH. WIRING DIAGRAMS GPC15[24-48]M41* Wiring is subject to change. Always refer to the wiring diagram on the unit for the most up-to-date wiring. 25