Download Polaroid PLA-4260 Television

Service Manual
Model #: PD-42S(PLA-4260)
Petters Consumer Brands
4400 Baker Road Minnetonka, MN 55343 U.S.A.
TEL : +952-936-5206
FAX : +952-975-4059
Top
Confidential
Table of Contents
CONTENTS
PAGE
Sections
1. Features
1-1
2. Specifications
2-1
3. On Screen Display
3-1
4. Factory Preset Timings
4-1
5. Pin Assignment
5-1
6. PDP Block Diagram
6-1
7. Control Board Internal I/O Connections
7-1
8. Remove the Burn-in mark
8-1
9. PDP Trouble Shooting
9-1
10. Spare Parts List
10-1
11. Complete Parts List
11-1
Appendix
1. Main Board Circuit Diagram
2. Main Board PCB Layout
3. Assembly Explosion Drawing
Block Diagram
PD-42S (PLA-4260) Service Manual
Polaroid
Service Manual
PD-42S (PLA-4260)
COPYRIGHT © 2000 . PETTERS CONSUMER BRANDS ALL RIGHTS RESERVED.
IBM and IBM products are registered trademarks of International Business Machines
Corporation.
Macintosh and Power Macintosh are registered trademarks of Apple Computer, Inc.
Petters and Petters products are registered trademarks of Petters Consumer Brands.
VESA, EDID, DPMS and DDC are registered trademarks of Video Electronics Standards
Association (VESA).
Energy Star is a registered trademark of the US Environmental Protection Agency (EPA).
No part of this document may be copied, reproduced or transmitted by any means for any
purpose without prior written permission from Petters.
FCC INFORMATION
This equipment has been tested and found to comply with the limits of a Class B digital device,
pursuant to part 15 of the FCC Rules. These limits are designed to provide reasonable
protection against harmful interference in a residential installation. This equipment generates,
uses and can radiate radio frequency energy, and if not installed and used in accordance with
the instructions, may cause harmful interference to radio communications. However, there is
no guarantee that the interference will not occur in a particular installation. If this equipment
does cause unacceptable interference to radio or television reception, which can be
determined by turning the equipment off and on, the user is encouraged to try to correct the
interference by one or more of the following measures -- reorient or relocate the receiving
antenna; increase the separation between equipment and receiver; or connect the into an
outlet on a circuit different from that to which the receiver is connected.
FCC WARNING
To assure continued FCC compliance, the user must use a grounded power supply cord and
the provided shielded video interface cable with bonded ferrite cores. Also, any unauthorized
changes or modifications to Amtrak products will void the user’s authority to operate this
device. Thus Petters Will not be held responsible for the product and its safety.
CE CERTIFICATION
This device complies with the requirements of the EEC directive 89/336/EEC with regard to
“Electromagnetic compatibility.”
SAFETY CAUTION
Use a power cable that is properly grounded. Always use the AC cords as follows – USA (UL);
Canada (CSA); Germany (VDE); Switzerland (SEV); Britain (BASEC/BS); Japan (Electric
Appliance Control Act); or an AC cord that meets the local safety standards.
PD-42S (PLA-4260) Service Manual
Chapter 1
Features
Wall-mountable
New WIDE XGA Plasma Panel:1024 x 768 (H x V)
Piano finish
Removable speaker system
Extremely thin: less than 100 mm
Fan-less
CONFIDENTIAL – DO NOT COPY
Page 1-1
File No. SG-0159
Chapter 2
Product Specification
1. CHARACTERISTICS of PDP module
Type: WXGA PLASMA DISPLAY
Size: 42 inch
Panel: Samsung S42AX-XD02
Active Screen Size (diagonal):42.32 inches (1,074.91mm)
Outline Dimension: Width 1015mm X Height 613mm X Thickness 67.5 mm
Pixel Pitch : 0.912 mm (H) X 0.693mm (V)
Color Depth 16.77M colors
Power Consumption 380 W + 10% (max)
Weight:
21kgs
2. Optical Characteristics
2-1 Viewing Angle > 160° (horizontal) / > 160° (vertical)
2-2 Contrast ratio (panel spec)
(w/glass filter)
3000:1 (Typical)
1500:1 (Typical)
3. System connection connectors
24-pin DVI-D, 20-pin DFP
4. POWER SUPPLY
Input voltage:
100-240Vac, 50/60Hz
Input current: 4A or less (at AC 120V/60Hz)
Inrush current: 60A at Vac=120V
Power consumption: 420 watts (max)
Stand-by: 5 watts max. (at 120 Vac)
Leakage current: No more than 1.3mA at 254Vac/50Hz for universal version
5. Speaker
a. Impedance: 8 Ohm +/- 15%
b. Frequency Range:
c. Power Input:
75 – 20K Hz
15W (max) x2
d. Terminal type: Push switch – polarity: positive (+)/red; negative (-)/black
CONFIDENTIAL – DO NOT COPY
Page 2-1
File No. SG-0159
6. ENVIRONMENT
a. Operating temperature: 5~35℃
b. Non-operating temperature: -5~50℃
c. Operating humidity: 20%~70% RH (No condensation)
d. Non-operating humidity:
20%~90% RH (No condensation)
e. Operating altitude: 0~6,560 ft
f. Non-operating altitude: 0~6,560 ft
7. OUTLINE DIMENSIONS (with speaker and base)
a. Height: 820mm
b. Width: 1095mm
c. Depth: 285 mm
8. WEIGHT (with speaker and base)
a. Net: 49.8 kgs +/- 0.5 kgs
b. Gross: 66+/- 0.5 kgs (packed together with set-top box)
9. Warning/Caution/Notice
To prevent possible danger, damage and bodily harm, please consider and observe all
warnings and cautions contained in this paragraph while handling the product or PDP
module only.
This product/PDP module is composed of various kinds of materials such as glass panel,
metals and plastics.
A qualified service technician is required for the disposal of the
module.
9.1 Warning
If you do not consider the following warnings, it could result in death or serious injury.
(1) Do not use any other power supply voltage other than the voltage specified in this
product specifications. If you use power voltage deviated from the specifications, it
could result in product failure.
(2) Do not operate or install under the deviated surroundings from the environmental
specification set for the below; in moisture, rain or near water-for example, bath tub,
laundry tub, kitchen sink; in a wet basement; or near a swimming pool; and also near
fire or heater - for example, near or over radiator or heat resistor; or where it is
exposed to direct sunlight; or somewhere like that. If you use the product/PDP module
in places mentioned above, it could result in electric shock, fire hazard or product
failure.
CONFIDENTIAL – DO NOT COPY
Page 2-2
File No. SG-0159
(3) If any foreign objects (e.g. water, liquid and metallic chip or dust) entered the
product/PDP module, the power supply voltage to the product/PDP module must be
turned off immediately. Also, never push objects of any kind into the PDP module as
they may touch dangerous voltage point or make short circuits that could result in fire
hazard or electric shock.
(4) If smoke, offensive smell or unusual noise should come from the product/PDP Module,
the power supplymust be turned off immediately. Also, when the screen fails to display
any picture after the power-on or during operation, the power supply must be turned
off immediately. Do not continue to operate the product/PDP module under these
conditions.
(5) The PDP module is controlled by high voltage about 350V. If you need to handle the
module during operation or just after power off, you must take proper precautions
against electric shock and must not touch the drive circuit portion and metallic part
within 5 minutes.
The capacitors in the drive circuit portion remain temporarily
charged even after the power is turned off.
After turning off the power, you must be
sure to wait at least one minute before touching the module.
If the remain voltage is
strong enough, it could result in electric shock.
(6) Do not disconnect or connect the PDP module’s connector while the power is on, or
immediately after power off. Because the module is operated by high voltage, and the
capacitors in drive circuit remain temporarily charged even after the power is turned
off.
If you need to disconnect or reconnect it, you have to wait at least one minute
after power off.
(7) Do not disconnect or connect the power connector by a wet hand.
The voltage of the
product/PDP module may be strong enough to cause an electric shock.
(8) Do not damage the power cable. Do not modify it either.
(9) When the power cable or connector is damaged or frayed, do not use it.
(10) When the power connector is covered with dust, please wipe it out with a dry cloth
before the power on.
CONFIDENTIAL – DO NOT COPY
Page 2-3
File No. SG-0159
9.2 Caution
If you do not consider the following cautions, it may result in personal injury or damage
(1)Do not set the product/PDP module on an unstable place, vibrating place and inclined
place. The product/PDP module may fall or collapse, and it may cause serious injury
to a person, and serious damage to the product.
(2) If you need to move the product/PDP module to another place, you must turn off the
power supply and detach the interface cable and power cable from the product/PDP
module beforehand.
If the cables are damaged during the transport, it may result in
fire hazard or electric shock.
Also if the product/PDP module has dropped or fallen,
it may cause a serious injury to a person.
(3) When you draw or insert the cables, you must turn off the power and do it by holding
the connector. If you forcibly draw the cable, the electric wire in the cable can be
exposed or broken.
It may result in fire hazard or electric shock.
(4) When you carry the product/PDP module, it should be done by at least two persons in
order to avoid any unexpected accidents.
(5) When you carry the product, do not hold the speaker and the bottom of black front
bezel to avoid any injuries to a person or damage to the product.
(6) When you detach the speaker net, do not hold the net surface to avoid deformation.
Please hold the edges.
(7) The product has a glass filter on it and the PDP module has a glass-plate.
If the
product/PDP module is inflicted with excessive stress – for example: excessive shock,
vibration, bending or heat-shock, the glass could be broken.
personal injury.
It may result in a
Also, do not press or strike the glass surface.
(8) If the glass is broken, do not touch it with bare hand.
(9) Do not place any objects on the glass panel.
It may be the cause of the scratch or
breakage.
CONFIDENTIAL – DO NOT COPY
Page 2-4
File No. SG-0159
(10) When the black front bezel of the product is covered with dust, please use a dry cloth
to wipe it off and afterwards may apply water or a natural detergent to a piece of soft
cloth or gauze, and wring the cloth tightly to clean.
9.3 Additional notice to the operation and handling of the PDP module
(1) To prevent defect or failure, please check the cable connections and power-supply
condition before power on.
(2) To ensure reliable operation of the module and to protect it from overheating, do not
wrap or cover it with a cloth or like a sheet during power-on. Also don not place the
module in a confined space or any other places of poor ventilation.
(3) The screen is controlled with the display-data signals and synchronized signals.
If
noise interferes with those signals, the screen could become unstable and in some
case would cause a failure.
Do not place any equipment that generates excessive
EMI/RFI noise near the interface cable of the module.
(3) Be careful not to break the glass panel when you handle the module.
Also when
handling the module, you must wear gloves or other hand protection to prevent
injuries that can occur in case the glass is broken.
(4) The glass panel section and drive circuit section of the module are closely connected
and they function as a pair.
If the module is arbitrarily recombined, restructured, or
disassembled. AmTRAN will not be responsible for the function, quality or operational
integrity of the modified module. Please do not recombine, restructure, or
disassemble it.
(5) To avoid a possible electric shock, you must make sure that the power supply of this
module is turned off before cleaning.
To clean the module’s panel, apply water or a
natural detergent to a piece of soft cloth or gauze, and wring the cloth tightly before
wiping the screen.
Make sure that no water comes in contact with the connecting
terminals on the side of the glass panel.
Do not use chemical solvents, such as
painter thinner or benzene to clean the glass panel.
CONFIDENTIAL – DO NOT COPY
Page 2-5
File No. SG-0159
(6) When storing the module, you must select an environmentally controlled space.
Avoid any environment in which the temperature or humidity exceeds the
specification values.
If you are storing the module for a long period of time, we
recommended that you place the module together with a dehumidifying agent, such
as silica gel, in a moisture-proof bag and keep it in an environmentally controlled
place.
9-4 Notice to handling the glass filter
(1) When the protection film is peeled off, static electricity is generated between the film
and polarizer. This should be peeled off slowly and carefully by people who are
electrically grounded and with wellion-blown equipment or in such a condition, etc.
(2) To clean the glass filter, you may follow the methods of PDP module mentioned
above.
CONFIDENTIAL – DO NOT COPY
Page 2-6
File No. SG-0159
Chapter 3
On Screen Display
Main unit button
STANDY/ON
VOLUME +
VOLUME CHANNEL +
CHANNEL INPUT
OSD Adjustment
Inputs
PC
DVI-HDCP
VIDEO 1
VIDEO 2
VIDEO 3
VIDEO 4
VIDEO 5
TV
1. VIDEO
A. PICTURE MODE
1. MOVIE
2. STANDARD
3. VIVID
4. SPORTS
B. BRIGHTNESS (0~100) (default:50)
C. CONTRAST (0~100) (default:50)
D. SATURATION (0~100) (default:50)
E. HUE (-50~50) (default:0)
F. SHARPNESS (0~14)
2. PC
A. AUTO( YES/NO)
B. COLOR TEMP (WARM/NORMAL/COOL)
C. CLOCK (0~100)
D. PHASE (0~255)
E. POSITION
1. X (0~100,step 1)
2. Y(0~100,step 1)
CONFIDENTIAL – DO NOT COPY
Page 3-1
File No. SG-0159
3. AUDIO
A. BASS
(0~100)
B. TREBLE (0~100)
C. BALANCE (-10~10)
D. SRS TS XT (OFF/ON)
4. PIP
A. PIP POSITION
1. X (0~100, step:1)
2. Y (0~100, step:1)
B. PIP SIZE
1. OFF
2. SMALL
3. MEDIUM
4. PBP
5. TV
A. SYSTEM
1. ANTENNA
2. STANDARD - CABLE
3. HRC - CABLE
4. IRC – CABLE
B. CHANNEL EDIT
1. AUTO PROGRAM
2. ADD
3. DELETE
CONFIDENTIAL – DO NOT COPY
Page 3-2
File No. SG-0159
6. PARENTAL
A. LOCK MENU
B.NEW PASSWORD
C. MPAA RATING (NA/ G/ PG/ PG-13/ R/ NC-17/ X)
D. TV PG RATING
1. NONE
2. TV-Y
3. TV – Y7 (F VIOLENCE)
4. TV - G
5. TV – PG (VIOLENCE /SEXUAL CONTENT/FOUL LANGUAGE/
SUGGESTIVE DIA)
6. TV – 14 (VIOLENCE/ SEXUAL CONTENT/ FOUL LANGUAGE/
SUGGESTIVE DIA)
7. TV-MA (VIOLENCE/ SEXUAL CONTENT/FOUL LANGUAGE)
7. SETTING
A. OSD LANGUAGE (ENGLISH/ FRANÇAIS/ESPAÑOL)
B. FIRMWARE VER (Vx.xx)
C. RESTORE DEFAULT (YES/ NO)
D. TRANSPARENCY
E. CC CONTROL (ON/OFF)
F. MODE (CC1/CC2/CC3/CC4/TEXT1/TEXT2/TEXT3/TEXT4)
8. DISPLAY (BOX/ SHADOW)
CONFIDENTIAL – DO NOT COPY
Page 3-3
File No. SG-0159
Chapter 4
Factory preset timings
This timing chart is preset for the Digital plasma monitor.
Mode
No.
1
Refresh Horizontal
Resolution
1024x768
Vertical
Rate
Frequency
Frequency
(Hz)
(KHz)
(Hz)
60
48.363
60.004
Horizontal Vertical
Sync
Sync
Polarity Polarity
(TTL)
N
(TTL)
N
Pixel
Rate
Remark
(MHz)
65.000
Windows
Remark: 1. N: negative,
2. This device has no scalars. Some DVI cards will lead to 1 pixel shift even with the
same resolution.
CONFIDENTIAL – DO NOT COPY
Page 4-1
File No. SG-0159
Chapter 5
Pin Assignment
The plasma monitor uses a 24-pin DVI-D connector as a video input interface while connecting to the
PLA-4260 set-top box with a system cable.
Pin Number
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
Signal Name
RX2RX2+
GND
Reserved 4
Reserved 5
DDC-CLK
DDC-DAT
Reserved 8
RX1RX1+
GND
Reserved 12
Reserved 13
VCCX
GND
SENS
RX0RX0+
GND
Reserved 20
Reserved 21
GND
RXC+
RXC-
CONFIDENTIAL – DO NOT COPY
Pin Function
TMDS negative differential input, channel 2
TMDS positive differential input, channel 2
Logic Ground
Reserved. No connection
Reserved. No connection
DDC2B Clock
DDC2B Data
Reserved. No connection
TMDS negative differential input, channel 1
TMDS positive differential input, channel 1
Logic Ground
Reserved. No connection
Reserved. No connection
Power
Logic Ground
SENSE Pin, Pull High
TMDS negative differential input, channel 0
TMDS positive differential input, channel 0
Logic Ground
Reserved. No connection
Reserved. No connection
Logic Ground
TMDS positive differential input, reference clock
TMDS negative differential input, reference clock
Page 5-1
File No. SG-0159
The plasma monitor uses a 20-pin DFP connector as an audio input interface and system control while
connecting to the PLA-4260 set-top box with a system cable.
Pin Number
Pin Function
Pin Number
Pin Function
1
IR
11
Audio_R
2
Ground
12
N.C
3
Ground
13
Ground
4
DB15_Hot Plug
14
+3.3V
5
+5V
15
+5V
6
N.C
16
SDO/TDO (CPLD ISP Pin)
7
TxD
17
SDI/TDI (CPLD ISP Pin)
8
RxD
18
MODE/TMS (CPLD ISP Pin)
9
Audio_L
19
Ground
10
N.C
20
SCK/TCK (CPLD ISP Pin)
Remarks : 16,17,18,20 (CPLD In system programmable)
CONFIDENTIAL – DO NOT COPY
Page 5-2
File No. SG-0159
Chapter 6
PDP Block Diagram
System Block Diagram
PDP PANEL
POWER
BOARD
LOGIC
BOARD
LA01
CN9004
J2
W4
W1
IR/LED
BOARD
W2
KEYPAD
BOARD
W3
control
board
CN2
AUDIO
POWER SUPPLY
CN1
EMI
FILTER
J5 J4
W5
SYSTEM
LEFT
W6
DVI_IN
AC
INPUT
RIGHT
SPEAKER
The PDP system block diagram is powered by AC source of 100V~240V AC +/- 10%
@ 50/60 HZ ,another audio power supply that transforms AC source of 100V~240V AC
+/- 10% @ 50/60 HZ into DC 18V source. The DC 18V source supplies the audio AMP
of control board. The digital IC parts of control board is powered by DC 5V from PDP
panel side.
CONFIDENTIAL – DO NOT COPY
Page 6-1
File No. SG-0159
PDP panel
Block Diagram
CONFIDENTIAL – DO NOT COPY
Page 6-2
File No. SG-0159
Control board
Block Diagram
DVI
RECEIVER
SIL161
DVI_IN
RGB24BIT
HS/VS/DE
HS/VS/DE
LVDS
TRANSMITTER
DS90C387
PDP
LOGIC
BOARD
CPLD
LC4128V
RS232
SYSTEM_IN
up
SM5964
IR/LED BOARD
KEYPAD
AUDIO_L/R
Audio
amp
TDA8947J
CONFIDENTIAL – DO NOT COPY
SPEAKER
Page 6-3
File No. SG-0159
Chapter 7
Control Board Internal I/O Connections
W1 CONNECTION (TOP→BOTTOM) "DC POWER INPUT/OUTPUT”
Pin
Description
1
“+5VSB_INPUT”
2
“+5VSB_INPUT”
3
“+5VSB_INPUT”
4
“D_GND”
5
“D_GND”
6
“D_GND”
7
“PDP_RELAY_ON”
8
N.C.
W2 CONNECTION (TOP→BOTTOM) “IR/LED_BOARD_CONTROL”
Pin
Description
1
“+5VSB_OUTPUT”
2
“IR_DATA_IN”
3
“LED_BLUE”
4
“D_GND”
5
“LED_RED”
6
N.C.
W3 CONNECTION (TOP→BOTTOM) “KEY_PAD”
CONFIDENTIAL – DO NOT COPY
Pin
Description
1
“POWER_KEY”
2
“N.C.”
3
“N.C.”
4
“VOL-_KEY
5
“GND”
6
“VOL+_KEY
7
“CH-_KEY
8
“CH+_KEY
9
“SOURCE
Page 7-1
File No. SG-0159
W4 CONNECTION (RIGHT->LEFT)”VIDEO(LVDS) SIGNAL TRANSMITION”
Pin
Description
1
“D_GND”
2
“N.C.
3
“D_GND”
4
“N.C.”
5
“N.C.”
6
“D_GND”
7
“D_GND”
8
“N.C.”
9
“N.C.”
10
“N.C.”
11
“N.C.”
12
“N.C.”
13
“N.C.”
14
“D_GND”
15
“N.C.”
16
“N.C.”
17
“TXD+”
18
“TXD-“
19
“TXCLK+”
20
“TXCLK-“
21
“D_GND”
22
“TXC+”
23
“TXC-“
24
“TXB+”
25
“TXB-“
26
“TXA+”
27
“TXA-“
28
“D_GND”
29
“D_GND”
30
“D_GND”
CONFIDENTIAL – DO NOT COPY
Page 7-1
File No. SG-0159
J2
J4
J5
CONNECTION (RIGHT→LEFT) “AUDIO_POWER_INPUT”
Pin
Description
1
“+18V”
2
“+18V”
3
“+18V”
4
“A_GND”
5
“A_GND”
6
“A_GND”
CONNECTION (RIGHT→LEFT) “SPEAKER_OUT”
Pin
Description
1
“RIGHT-”
2
“RIGHR+”
CONNECTION (RIGHT→LEFT) “SPEAKER_OUT”
Pin
Description
1
“LEFT+”
2
“LEFT-”
CONFIDENTIAL – DO NOT COPY
Page 7-1
File No. SG-0159
Chapter 8
Remove the Burn-in mark
To remove burn-in mark on the PDP
1
Be sure the set-top box is connected well.
2
Select TV as main source.
3
Turn off PIP window if any.
4
Press the password on the remote control:
“SWAP” -> “UP” -> “UP” -> “DOWN” -> “DOWN” -> “SELECT”
5
Burn-in mode starts. You will see red, green, blue and white screens display.
Keep them displaying at least 8 hours.
6
Press “EXIT” key to exit the burn-in mode and check if the mark is still visible. If so,
you may carry on the steps from 10.4.
CONFIDENTIAL – DO NOT COPY
Page 8-1
File No. SG-0159
Chapter 9
PDP Trouble Shooting
PDP DISPLAY NOTHING(MONITOR ONLY WIHOUT BOX)
START
AC POWER
input ?
SET AC POWER SWITCH TO ON
DVI has
signal ?
1.check DVI cable connection
2.set your PC resolution to 1024x768 /60HZ
3.set your PC display card to DVI output
4.set PDP AC switch to OFF then ON
internal
cable ?
check all internal cable have be connected.
DC
power?
Hsync,
Vsync,DE
have signal?
1.check U2 input has +5V
2.check U2 output has +3.3V
3.check RELAY_ON signal is low
1.check U10 have output Hsync/Vsync/DE signal
2.check U15 have output Hsync/Vsync/DE signal
3.check U7 have output LVDS signal
END
CONFIDENTIAL – DO NOT COPY
Page 9-1
File No. SG-0159
PDP DISPLAY NOTHING( WITH BOX)
START
AC POWER
input ?
DVI&
SYSTEM
CABLE OK?
internal
cable ?
DC
power?
Hsync,
Vsync,DE
have
signal?
SET AC POWER SWITCH TO ON
1.check DVI&SYSTEM cable connection
2.check input source what you select
3.set input source to what you select
check all internal cable have be connected.
1.check U2 input has +5V
2.check U2 output has +3.3V
3.check RELAY_ON signal is low
1.check U10 have output Hsync/Vsync/DE signal
2.check U15 have output Hsync/Vsync/DE signal
3.check U7 have output LVDS signal
END
CONFIDENTIAL – DO NOT COPY
Page 9-2
File No. SG-0159
PDP NO SOUND( WITH BOX)
START
AC POWER
input ?
DVI&
SYSTEM
CABLE OK?
internal
cable ?
DC
power?
speaker
output?
SET AC POWER SWITCH TO ON
1.check DVI&SYSTEM cable connection
2.check input source(video&audio) what you select
3.set input source to what you select
check all internal cable have be connected.
1.check
2.check
3.check
4.check
U2 input has +5V
U2 output has +3.3V
RELAY_ON signal is low
F1 has +18V
1.check U8 have audio input signal
2.check U8 MODE1 pin signal is +18V
3.check Q5 Gate pin has +5V
END
CONFIDENTIAL – DO NOT COPY
Page 9-3
File No. SG-0159
TROUBLE OF DDC READING
Start
Yes
N0
Digital DDC OK?
Support DDC2B
1.Digital cable ok?
2.Voltage of VCCX ok?
3.Check U32
5.Is compliant protocol?
Yes
END
CONFIDENTIAL – DO NOT COPY
Page 9-4
File No. SG-0159
Chapter10 Spare Parts List
PD-42S / PLA-4260
PART NO
DESCRIPTION
LOC
QTY
0185-1402-0003
FUSE 125V/4A SMD (R451004)
F1
1
0420-1002-4611
MOSFET N-CH 2N7002 SMD (SOT-23)
Q10,Q2
2
0420-2003-1626
MOSFET P-CH 9A 30V P2003EV SOP-8
Q1
1
0430-4009-3109
IC TDA8947J DIP 17PIN
U8
1
0430-6005-6004
IC LM1117MPX-ADJ SMD 3PIN (SOT-223)
U2
1
1801-0117-4010
FRONT BEZEL (PD-42S)(ABS, 877C) ASS'Y
1
1925-1000-2150
CUSHION-R (AVC42)
2
1925-1000-2170
EPE FOAM-B (PD-42S)
1
1925-1000-2180
EPE FOAM-T (PD-42S)
1
1925-1000-2430
EPE FOAM-F (PD-42S)
1
1925-1100-1760
PE BAG (1300.0*1200.0*0.4t)(PD-42S)
1
1925-1200-6850
CARTON BLANK (PD-42S)
1
1925-1200-7210
ACCESSARY BOX (366.0L*232.0D*71.0H)
1
1925-1900-0490
GUARDBOARD 40.0*40.0*430.0mm (PD-42S)
4
1947-1200-0400
ACETATE CLOTH TAPE ( 醋酸布膠帶 ) 20*45mm
5
1947-1200-2290
Insulator (300*150*0.25t)
1
1947-1200-2300
Insulator (8*170*0.25t )
1
1947-1400-0110
SPEAKER FRONT BEZEL NET (PD-42S)
1
1947-1500-2160
PANEL CUSHION 950.0*10.0*7.0mm (PD-42S)
2
1947-1500-2170
PANEL CUSHION 550.0*10.0*7.0mm (PD-42S)
2
1947-1500-2180
SPONGE (PD-42S)
4
1947-1700-0240
GASKET BLOCK (40*4.0*1.0)
2
1947-1700-1100
GASKET BLOCK (20.0*13.0*10.0)
2
1947-1800-0150
GASKET EMI (17*25*210mm)
6
1947-1800-0240
GASKET EMI (5*1*100mm)
2
1947-1800-0370
GASKET BLOCK (5.5H*10.0W*30.0Lmm)
1
1947-1800-0670
Gasket Block (10W*3H*80L mm)
7
1947-1800-0690
Gasket Block (20W*0.3H*583L mm)
2
1947-1800-0700
Gasket Block (20W*0.3H*983L mm)
2
1947-1800-0710
Gasket Block (17.0W*1.0H*41.0L)
2
1947-1800-0780
Gasket Block (5W*2H*300L)
1
1947-1900-0030
HEATPATH (25x14mm)
1
CONFIDENTIAL – DO NOT COPY
REMARK
Page 10-1
File No. SG-0159
PART NO
DESCRIPTION
1947-2400-0010
SPEAKER LOWER ASS'Y (PD-42S)
3842-0012-0154
PDP CONTROL BD ASS'Y (PD-42S)
3842-0012-0307
SWITCH ASS'Y (PD-42S)
3842-0022-0156
PDP DISPLAY BD ASS'Y (PD-42S)
3842-0032-0189
PDP IR BD ASS'Y (PD-42S)
CONFIDENTIAL – DO NOT COPY
LOC
QTY
REMARK
1
Page 10-2
File No. SG-0159
Chapter 11 Complete Parts List
2842-4203-0004
ITEM
M/S
Plasma monitor 42'' (PD-42S)(ABS,BLACK)
LOCATION
PART NO.
DESCRPTION
QTY
1
3842-0022-0301
PDP BASE ASS'Y (PD-42S)(ABS, 877C)
1
2
3842-0022-0303
PDP CHASSIS ASS'Y (PD-42S)
1
3
3842-0022-0312
PDP PACKING ASS'Y (PD-42S)
1
CONFIDENTIAL – DO NOT COPY
Page 11-1
File No. SG-0159
3842-0022-0301
ITEM
M/S
PDP BASE ASS'Y (PD-42S)(ABS, 877C)
LOCATION
PART NO.
DESCRPTION
QTY
1
1701-0515-1010
Base Cover (PD-42S)(ABS, 5108M)
1
2
1701-1000-0350
BASE FOOT ( φ 30.0mm t=1mm)(PD-42S)
6
3
1712-0100-6790
Base Plate (SECC t=2.2mm)(PD-42S)
1
4
1712-1200-0070
BASE
2
5
1720-1306-1850
MAC. SCREW-MPSW M6.0*18.0L, BLK- Ni
8
6
1720-3006-1550
MAC. SCREW-MF M6.0*15.0L, BLK-Ni
8
7
1721-3047-1220
TAP SCREW-MF #4.7*12.0L, Ni
14
8
1947-1400-0110
SPEAKER FRONT BEZEL NET (PD-42S)
1
9
1947-2400-0010
SPEAKER LOWER ASS'Y (PD-42S)
1
CONFIDENTIAL – DO NOT COPY
Die (PD-42S)
Page 11-2
File No. SG-0159
3842-0022-0303
ITEM
M/S
PDP CHASSIS ASS'Y (PD-42S)
LOCATION
PART NO.
DESCRPTION
QTY
1
0213-0420-0967
PDP MODULE 42'' S42AX-XD02 (SAMSUNG)
1
2
0220-8020-0881
SW ROCKERSW 250V 6A 2P HF606A1BBATA
1
3
0260-0000-0210
LINE FILTER ASS'Y 6A 06DBDW3S-AM01
1
4
0460-1006-0202
WH PH6P-PH5P 1061#26 600mm CORE*1 SHIELDING
1
5
0460-1009-0411
WH PH9P-PH7P+SRA4.3*2 1061#26 710mm CORE*1
1
6
0460-1106-0160
WH XH6P-XH6P 1007#24 250mm
1
7
0460-1211-0020
WH 35572-11P-XH8P 2P 120mm
1
8
0460-3430-0540
WH FI-W31S/DF14-30S 20276#30 160mm
1
9
0500-0502-0030
POWER BD ASS'Y 18V 4.5A (0432D1881)
1
10
1701-0414-9010
Button (PD-42S)(ABS, 877C)
1
11
1701-0900-1300
Samsung 42'' PDP EMI Filter ,Mesh Type (42S3)
1
12
1701-0900-1350
WASHER (FR63, 0.5t)(F19R31)
4
13
1701-1500-0450
WIRE SADDLE (CH-01B)
8
14
1701-1919-1010
HANDLE (PC+ABS, Black)(PD-42S)
2
15
1712-0100-4590
HEAT SINK FIX MTEAL (TM-30A)
1
16
1712-0100-6740
Filter Clip (SECC t=1.0MM)(PD-42S)
10
17
1712-0100-6750
Main Frame Lateral High (SECC t=2.0mm)(PD-42S)
1
18
1712-0100-6760
Main Frame Cross (SECC t=2.0MM)(PD-42S)
2
19
1712-0100-6770
Rear Cover ( SECC t=1.0mm)(PD-42S)
1
20
1712-0100-6780
Flat Metal (SECC t=1.0mm)(PD-42S)
2
21
1712-0100-6930
PCB Supportor (PD-42S)(SECC t=1.0mm)
1
22
1712-0100-6940
I/O Bracket (PD-42S)(SECC t=1.0mm)
1
23
1712-0100-7480
Main Frame Lateral Low (SECC t=2.0mm)(PD-42S)
1
24
1712-0400-0720
HEAT SINK (PD-42S)
1
25
1712-1200-0060
Stand
Frame (PD-42S)
2
26
1720-0003-0620
MAC. SCREW-MB M3.0*6.0L,Ni
16
27
1720-0004-1210
MAC. SCREW M4.0*12.0L, Zn-Cc
12
28
1720-1006-0820
MAC. SCREW-MP M6.0*8.0L, Ni
8
29
1720-1204-0820
MAC. SCREW-MPGW M4.0*8.0L,Ni
1
30
1720-1503-0620
MAC.SCREW-MPSWF M3.0*6.0L Ni
4
CONFIDENTIAL – DO NOT COPY
Page 11-3
File No. SG-0159
ITEM
M/S
LOCATION
PART NO.
DESCRPTION
QTY
31
1720-1505-1550
MAC. SCREW-MPSFW M5.0*15.0L, BLK-Ni
4
32
1720-5003-0550
MAC. SCREW-MI M3.0*5.0L, BLK-Ni
9
33
1720-7344-0820
MAC. SCREW-MHSW #4-40*8.0L,Ni
2
34
1721-0003-1050
TAP. SCREW-TB #3*10.0L, BLK-Ni
4
35
1721-0004-1050
TAP. SCREW-TP #4.0*10.0L, BLK-Ni
52
36
1721-5003-0520
TAP. SCREW-TI M3.0*5.0L,Ni
32
37
1801-0117-4010
FRONT BEZEL (PD-42S)(ABS, 877C) ASS'Y
1
38
1812-0100-6690
FilTER BKT ASS'Y (PD-42S)
1
39
1947-1200-0400
ACETATE CLOTH TAPE ( 醋酸布膠帶 ) 20*45mm
5
40
1947-1200-2290
Insulator (300*150*0.075t)
1
41
1947-1200-2300
Insulator (8*170*0.215t)
1
42
1947-1500-2160
PANEL CUSHION 950.0*10.0*7.0mm (PD-42S)
2
43
1947-1500-2170
PANEL CUSHION 550.0*10.0*7.0mm (PD-42S)
2
44
1947-1500-2180
SPONGE (PD-42S)
4
45
1947-1700-0240
GASKET BLOCK (40*4.0*1.0)
2
46
1947-1700-1100
GASKET BLOCK (20.0*13.0*10.0)
2
47
1947-1800-0150
GASKET EMI (17*25*210mm)
6
48
1947-1800-0240
GASKET EMI (5*1*100mm)
2
49
1947-1800-0370
GASKET BLOCK (5.5H*10.0W*30.0Lmm)
1
50
1947-1800-0670
Gasket Block (10W*3H*80L mm)
7
51
1947-1800-0690
Gasket Block (20W*0.3H*583L mm)
2
52
1947-1800-0700
Gasket Block (20W*0.3H*983L mm)
2
53
1947-1800-0710
Gasket Block (17.0W*1.0H*41.0L)
2
54
1947-1800-0780
Gasket Block (5W*2H*300L)
1
55
1947-1900-0030
HEATPATH (25x14mm)
1
56
3842-0012-0154
PDP CONTROL BD ASS'Y (PD-42S)
1
57
3842-0012-0307
SWITCH ASS'Y (PD-42S)
1
58
3842-0022-0156
PDP DISPLAY BD ASS'Y (PD-42S)
1
59
3842-0032-0189
PDP IR BD ASS'Y (PD-42S)
1
CONFIDENTIAL – DO NOT COPY
Page 11-4
File No. SG-0159
3842-0022-0312
ITEM
M/S
PDP PACKING ASS'Y (PD-42S)
LOCATION
PART NO.
DESCRPTION
QTY
1
1925-1000-2150
CUSHION-R (AVC42)
2
2
1925-1000-2170
EPE FOAM-B (PD-42S)
1
3
1925-1000-2180
EPE FOAM-T (PD-42S)
1
4
1925-1000-2430
EPE FOAM-F (PD-42S)
1
5
1925-1100-1760
PE BAG (1300.0*1200.0*0.4t)(PD-42S)
1
6
1925-1200-6850
CARTON BLANK (PD-42S)
1
7
1925-1900-0490
GUARDBOARD 40.0*40.0*430.0mm (PD-42S)
4
8
3842-0012-0393
PDP ACCESSORY ASS'Y (PD-42S)
1
CONFIDENTIAL – DO NOT COPY
Page 11-5
File No. SG-0159
3842-0012-0154
ITEM
M/S
PDP CONTROL BD ASS'Y (PD-42S)
LOCATION
PART NO.
DESCRPTION
QTY
1
384200120154A
PDP CONTROL BD ASS'Y (PD-42S) AI
1
2
384200120154M
PDP CONTROL BD ASS'Y (PD-42S) MI
1
3
384200120154S
PDP CONTROL BD ASS'Y (PD-42S) SMD
1
CONFIDENTIAL – DO NOT COPY
Page 11-6
File No. SG-0159
3842-0012-0307
ITEM
M/S
SWITCH ASS'Y (PD-42S)
LOCATION
PART NO.
DESCRPTION
QTY
1
0220-6020-0186
SW PUSH Terminal DIP 2PIN
2
2
0242-0225-1504
HEAT S-T 2.0*0.25 15MM 125'
4
3
0460-1102-0072
WH XH2P-NC 1007#24 540mm CORE*2
1
4
0460-1102-0082
WH XH2P-NC 1007#24 400mm CORE*2
1
CONFIDENTIAL – DO NOT COPY
Page 11-7
File No. SG-0159
3842-0012-0393
ITEM
M/S
PDP ACCESSORY ASS'Y (PD-42S)
LOCATION
PART NO.
DESCRPTION
QTY
1
0320-4000-0140
POWER CORD 1800mm 110V UL/CSA (BLK)(N.M.)
2
2
0321-0000-0251
DVI/D TYPE CABLE 3000mm BLK core*4
1
3
1925-1200-7210
ACCESSARY BOX (366.0L*232.0D*71.0H)
1
CONFIDENTIAL – DO NOT COPY
Page 11-8
File No. SG-0159
3842-0022-0156
ITEM
M/S
PDP DISPLAY BD ASS'Y (PD-42S)
LOCATION
1
PART NO.
DESCRPTION
QTY
0170-1740-1182
PCB DISPLAY BD V0 165.0*16.2*1.6t S (PD-42S)
1
2
SWK1
0220-7020-0965
SW TACT 6*6mm 180' 160g SFKHHAM2520
1
3
SWK2
0220-7020-0965
SW TACT 6*6mm 180' 160g SFKHHAM2520
1
4
SWK3
0220-7020-0965
SW TACT 6*6mm 180' 160g SFKHHAM2520
1
5
SWK4
0220-7020-0965
SW TACT 6*6mm 180' 160g SFKHHAM2520
1
6
SWK5
0220-7020-0965
SW TACT 6*6mm 180' 160g SFKHHAM2520
1
7
SWK6
0220-7020-0965
SW TACT 6*6mm 180' 160g SFKHHAM2520
1
8
W1
0451-2000-0766
WAFER 2.00MM 7P 90' KINK (STM)
1
CONFIDENTIAL – DO NOT COPY
Page 11-9
File No. SG-0159
3842-0032-0189
ITEM
M/S
PDP IR BD ASS'Y (PD-42S)
LOCATION
PART NO.
DESCRPTION
QTY
1
384200320189A
PDP IR BD ASS'Y (PD-42S) AI
1
2
384200320189M
PDP IR BD ASS'Y (PD-42S) MI
1
3
384200320189S
PDP IR BD ASS'Y (PD-42S) SMD
1
CONFIDENTIAL – DO NOT COPY
Page 11-10
File No. SG-0159
3842-0012-0154A
ITEM
M/S
1
2
PDP CONTROL BD ASS'Y (PD-42S) AI
LOCATION
C3
SS
PART NO.
DESCRPTION
0102-2102-1212
E/C L-L 1000uF/16V 105' NF-T 10*16 (KY)
0103-6102-1212
E/C HF 1000uF 16V 105'C F (10*20)
QTY
1
3
C5
0103-1471-1211
E/C VZ 470uF 16V 105'C F-T (8*11.5mm)
1
4
C50
0102-2102-1312
E/C L-L 1000UF 25V 105' F (KY TYPE)
1
5
C54
0103-1220-1511
E/C VT 22uF 50V 105'C F-T (5*11mm)
1
6
C56
0103-1229-1511
E/C VT 2.2uF 50V 105'C F-T (5*11mm)
1
0101-1229-1511
E/C GEN. 2.2UF 50V 105' F
7
SS
8
C57
0102-2221-1311
E/C L-L 220uF/25V 105' F 8*11.5 (KY)
1
9
C68
0103-1101-1211
E/C VZ 100uF 16V 105'C F-T (5*11mm)
1
10
C69
0103-1470-1211
E/C VT 47uF 16V 105'C F-T (5*11mm)
1
0101-1470-1211
E/C GEN. 47UF 16V 105' F
0103-1470-1211
E/C VT 47uF 16V 105'C F-T (5*11mm)
0101-1470-1211
E/C GEN. 47UF 16V 105' F
11
SS
12
13
C70
SS
1
14
C8
0103-1101-1211
E/C VZ 100uF 16V 105'C F-T (5*11mm)
1
15
C84
0103-1470-1211
E/C VT 47uF 16V 105'C F-T (5*11mm)
1
0101-1470-1211
E/C GEN. 47UF 16V 105' F
0103-1470-1211
E/C VT 47uF 16V 105'C F-T (5*11mm)
0101-1470-1211
E/C GEN. 47UF 16V 105' F
0103-1470-1211
E/C VT 47uF 16V 105'C F-T (5*11mm)
0101-1470-1211
E/C GEN. 47UF 16V 105' F
0390-6002-8272
SCHOTTKY DIODE 1A 40V SB140
16
SS
17
18
C85
SS
19
20
21
C86
SS
D22
CONFIDENTIAL – DO NOT COPY
1
1
1
Page 11-11
File No. SG-0159
3842-0012-0154M
ITEM
PDP CONTROL BD ASS'Y (PD-42S) MI
LOCATION
M/S
PART NO.
DESCRPTION
QTY
1
JP1
0455-2540-0479
PIN HEADER 2*2P 2.54mm 180'
1
2
J2
0451-2500-0616
WAFER 2.50MM 6P 180' KINK (STM)
1
3
J4
0451-2500-0216
WAFER 2.50mm 2P 180' KINK (STM)
1
4
J5
0451-2500-0216
WAFER 2.50mm 2P 180' KINK (STM)
1
5
U8
0430-4009-3109
IC TDA8947J DIP 17PIN
1
6
W1
0451-2500-0816
WAFER 2.50MM 8P 180' KINK (STM)
1
7
W2
0451-2000-0606
WAFER 2.00MM 6P 180'KINK
1
8
W3
0451-2000-0906
WAFER 2.00MM 9P 180'KINK (STM)
1
9
W5
0303-5000-2004
CONN D-TYPE 20PIN
1
10
W6
0302-3010-0240
DVI CONN R/A D 24PIN (DV2R024N11)
1
11
Y1
0280-2400-0115
X'TAL 24MHz 49/US 30PPM CL:18PF
1
CONFIDENTIAL – DO NOT COPY
Page 11-12
File No. SG-0159
3842-0012-0154S
ITEM
M/S
PDP CONTROL BD ASS'Y (PD-42S) SMD
LOCATION
1
PART NO.
DESCRPTION
QTY
0171-2141-0062
PCB CONTROL BD FR4 165.0*150.0*1.6t D (PD-42S)
1
2
CP1
0111-5103-5121
ARRAY CAP 0.01uF 50V X7R 8PIN
1
3
CP2
0111-5103-5121
ARRAY CAP 0.01uF 50V X7R 8PIN
1
4
C100
0112-3471-5106
C/M Multi. 470PF 50V NPO 0603
1
5
C101
0112-3471-5106
C/M Multi. 470PF 50V NPO 0603
1
6
C102
0112-3471-5106
C/M Multi. 470PF 50V NPO 0603
1
7
C21
0112-3104-5116
C/M Muitl. 0.1uF 50V X7R 0603
1
8
C22
0112-3106-1614
C/M MULTI 10uF 16V X7R 1206
1
9
C23
0112-3150-5106
C/M MULTI 15PF 50V NPO 0603
1
10
C24
0112-3150-5106
C/M MULTI 15PF 50V NPO 0603
1
11
C25
0112-3106-1614
C/M MULTI 10uF 16V X7R 1206
1
12
C26
0112-3104-5116
C/M Muitl. 0.1uF 50V X7R 0603
1
13
C27
0112-3104-5116
C/M Muitl. 0.1uF 50V X7R 0603
1
14
C28
0112-3104-5116
C/M Muitl. 0.1uF 50V X7R 0603
1
15
C29
0112-3104-5116
C/M Muitl. 0.1uF 50V X7R 0603
1
16
C30
0112-3104-5116
C/M Muitl. 0.1uF 50V X7R 0603
1
17
C31
0112-3104-5116
C/M Muitl. 0.1uF 50V X7R 0603
1
18
C32
0112-3104-5116
C/M Muitl. 0.1uF 50V X7R 0603
1
19
C33
0112-3104-5116
C/M Muitl. 0.1uF 50V X7R 0603
1
20
C34
0112-3104-5116
C/M Muitl. 0.1uF 50V X7R 0603
1
21
C35
0112-3104-5116
C/M Muitl. 0.1uF 50V X7R 0603
1
22
C36
0112-3104-5116
C/M Muitl. 0.1uF 50V X7R 0603
1
23
C37
0112-3104-5116
C/M Muitl. 0.1uF 50V X7R 0603
1
24
C40
0112-3101-5106
C/M Multi. 100PF 50V NPO 0603
1
25
C41
0112-3101-5106
C/M Multi. 100PF 50V NPO 0603
1
26
C42
0112-3101-5106
C/M Multi. 100PF 50V NPO 0603
1
27
C43
0112-3101-5106
C/M Multi. 100PF 50V NPO 0603
1
28
C44
0112-3101-5106
C/M Multi. 100PF 50V NPO 0603
1
29
C45
0112-3101-5106
C/M Multi. 100PF 50V NPO 0603
1
30
C49
0112-3104-5116
C/M Muitl. 0.1uF 50V X7R 0603
1
CONFIDENTIAL – DO NOT COPY
Page 11-13
File No. SG-0159
ITEM
M/S
LOCATION
PART NO.
DESCRPTION
QTY
31
C53
0112-3474-2515
C/M Multi. 0.47UF 25V X7R 0805
1
32
C58
0112-3105-2514
C/M Multi. 1.0uF 25V X7R 1206
1
33
C6
0112-3104-5116
C/M Muitl. 0.1uF 50V X7R 0603
1
34
C65
0112-3104-5116
C/M Muitl. 0.1uF 50V X7R 0603
1
35
C66
0112-3470-5106
C/M Multi. 47PF 50V NPO 0603
1
36
C67
0112-3470-5106
C/M Multi. 47PF 50V NPO 0603
1
37
C7
0112-3104-5116
C/M Muitl. 0.1uF 50V X7R 0603
1
38
C71
0112-3104-5116
C/M Muitl. 0.1uF 50V X7R 0603
1
39
C72
0112-3104-5116
C/M Muitl. 0.1uF 50V X7R 0603
1
40
C73
0112-3104-5116
C/M Muitl. 0.1uF 50V X7R 0603
1
41
C74
0112-3104-5116
C/M Muitl. 0.1uF 50V X7R 0603
1
42
C75
0112-3104-5116
C/M Muitl. 0.1uF 50V X7R 0603
1
43
C76
0112-3104-5116
C/M Muitl. 0.1uF 50V X7R 0603
1
44
C77
0112-3104-5116
C/M Muitl. 0.1uF 50V X7R 0603
1
45
C78
0112-3104-5116
C/M Muitl. 0.1uF 50V X7R 0603
1
46
C79
0112-3104-5116
C/M Muitl. 0.1uF 50V X7R 0603
1
47
C80
0112-3104-5116
C/M Muitl. 0.1uF 50V X7R 0603
1
48
C81
0112-3104-5116
C/M Muitl. 0.1uF 50V X7R 0603
1
49
C82
0112-3104-5116
C/M Muitl. 0.1uF 50V X7R 0603
1
50
C83
0112-3104-5116
C/M Muitl. 0.1uF 50V X7R 0603
1
51
C87
0112-3101-5106
C/M Multi. 100PF 50V NPO 0603
1
52
C88
0112-3474-2515
C/M Multi. 0.47UF 25V X7R 0805
1
53
C89
0112-3104-5116
C/M Muitl. 0.1uF 50V X7R 0603
1
54
C90
0112-3104-5116
C/M Muitl. 0.1uF 50V X7R 0603
1
55
C91
0112-3104-5116
C/M Muitl. 0.1uF 50V X7R 0603
1
56
C92
0112-3104-5116
C/M Muitl. 0.1uF 50V X7R 0603
1
57
C93
0112-3104-5116
C/M Muitl. 0.1uF 50V X7R 0603
1
58
C94
0112-3104-5116
C/M Muitl. 0.1uF 50V X7R 0603
1
59
C95
0112-3104-5116
C/M Muitl. 0.1uF 50V X7R 0603
1
60
C96
0112-3104-5116
C/M Muitl. 0.1uF 50V X7R 0603
1
61
C97
0112-3104-5116
C/M Muitl. 0.1uF 50V X7R 0603
1
62
C98
0112-3104-5116
C/M Muitl. 0.1uF 50V X7R 0603
1
63
C99
0112-3471-5106
C/M Multi. 470PF 50V NPO 0603
1
CONFIDENTIAL – DO NOT COPY
Page 11-14
File No. SG-0159
ITEM
64
65
D10
SS
66
67
LOCATION
M/S
D11
SS
68
D12
PART NO.
DESCRPTION
0390-5001-9293
DUAL SURFACE DIODES BAV99 SMD (SOT-23)
0390-5001-9133
DUAL SURFACE DIODE BAV99 SMD (SOT-23)
0390-5001-9293
DUAL SURFACE DIODES BAV99 SMD (SOT-23)
0390-5001-9133
DUAL SURFACE DIODE BAV99 SMD (SOT-23)
0390-5000-1053
GEN. DIODE 1N4148 SMD
69
CS
0390-5000-1093
GEN. DIODE FDLL4148 SMD
70
CS
0390-5000-1223
GEN. DIODE RLS4148 SMD
0390-5001-9293
DUAL SURFACE DIODES BAV99 SMD (SOT-23)
0390-5001-9133
DUAL SURFACE DIODE BAV99 SMD (SOT-23)
0390-5001-9293
DUAL SURFACE DIODES BAV99 SMD (SOT-23)
0390-5001-9133
DUAL SURFACE DIODE BAV99 SMD (SOT-23)
0390-5000-1053
GEN. DIODE 1N4148 SMD
71
72
D18
SS
73
74
D19
SS
75
D20
76
CS
0390-5000-1093
GEN. DIODE FDLL4148 SMD
77
CS
0390-5000-1223
GEN. DIODE RLS4148 SMD
0390-5001-9293
DUAL SURFACE DIODES BAV99 SMD (SOT-23)
0390-5001-9133
DUAL SURFACE DIODE BAV99 SMD (SOT-23)
0390-5001-9293
DUAL SURFACE DIODES BAV99 SMD (SOT-23)
0390-5001-9133
DUAL SURFACE DIODE BAV99 SMD (SOT-23)
0390-5001-9293
DUAL SURFACE DIODES BAV99 SMD (SOT-23)
0390-5001-9133
DUAL SURFACE DIODE BAV99 SMD (SOT-23)
0390-5001-9293
DUAL SURFACE DIODES BAV99 SMD (SOT-23)
0390-5001-9133
DUAL SURFACE DIODE BAV99 SMD (SOT-23)
0390-5001-9293
DUAL SURFACE DIODES BAV99 SMD (SOT-23)
0390-5001-9133
DUAL SURFACE DIODE BAV99 SMD (SOT-23)
0390-5001-9293
DUAL SURFACE DIODES BAV99 SMD (SOT-23)
0390-5001-9133
DUAL SURFACE DIODE BAV99 SMD (SOT-23)
78
79
D4
SS
80
81
D5
SS
82
83
D6
SS
84
85
D7
SS
86
87
D8
SS
88
89
D9
SS
QTY
1
1
1
1
1
1
1
1
1
1
1
1
90
F1
0185-1402-0003
FUSE 125V/4A SMD (R451004)
1
91
L10
0130-0000-1859
RES. CF 0.0ohm 1/4W J 1206
1
92
L11
0111-3103-5116
C/M MULTI 0.01UF 50V X7R 0603
1
93
L12
0111-3103-5116
C/M MULTI 0.01UF 50V X7R 0603
1
94
L13
0111-3103-5116
C/M MULTI 0.01UF 50V X7R 0603
1
95
L14
0370-0000-6452
CHIP BEAD CORE 80ohm (MLB-201209-0080A-N2)
1
96
L15
0370-0000-6452
CHIP BEAD CORE 80ohm (MLB-201209-0080A-N2)
1
CONFIDENTIAL – DO NOT COPY
Page 11-15
File No. SG-0159
ITEM
LOCATION
M/S
PART NO.
DESCRPTION
QTY
97
L16
0370-0000-6452
CHIP BEAD CORE 80ohm (MLB-201209-0080A-N2)
1
98
L17
0370-0000-6452
CHIP BEAD CORE 80ohm (MLB-201209-0080A-N2)
1
99
L18
0370-0000-4651
CHIP BEAD CORE 80ohm (MLB-321611-0080P-N1)
1
100
L4
0111-3103-5116
C/M MULTI 0.01UF 50V X7R 0603
1
101
L5
0111-3103-5116
C/M MULTI 0.01UF 50V X7R 0603
1
102
Q1
0420-2003-1626
MOSFET P-CH 9A 30V P2003EV SOP-8
1
103
Q10
0420-1002-4611
MOSFET N-CH 2N7002 SMD (SOT-23)
1
104
Q2
0420-1002-4611
MOSFET N-CH 2N7002 SMD (SOT-23)
1
105
Q9
0410-5000-1610
TRANSISTOR MMBT3904LT1 SMD T
1
0410-5000-1604
TRANSISTOR 2N3904 SMD T
106
CS
107
RP1
0141-1001-3851
ARRAY RES. A(X) 1Kohm 4R J 8P
1
108
RP10
0141-0000-3851
ARRAY RES. A(X) 0.0ohm 4R J 8P
1
109
RP11
0141-0000-3851
ARRAY RES. A(X) 0.0ohm 4R J 8P
1
110
RP12
0141-0000-3851
ARRAY RES. A(X) 0.0ohm 4R J 8P
1
111
RP13
0141-0000-3851
ARRAY RES. A(X) 0.0ohm 4R J 8P
1
112
RP14
0141-0000-3851
ARRAY RES. A(X) 0.0ohm 4R J 8P
1
113
RP15
0141-0000-3851
ARRAY RES. A(X) 0.0ohm 4R J 8P
1
114
RP16
0141-2209-3851
ARRAY RES. A(X) 22ohm 4R J 8P
1
115
RP17
0141-2209-3851
ARRAY RES. A(X) 22ohm 4R J 8P
1
116
RP18
0141-0000-3851
ARRAY RES. A(X) 0.0ohm 4R J 8P
1
117
RP19
0141-2209-3851
ARRAY RES. A(X) 22ohm 4R J 8P
1
118
RP2
0141-1001-3851
ARRAY RES. A(X) 1Kohm 4R J 8P
1
119
RP20
0141-2209-3851
ARRAY RES. A(X) 22ohm 4R J 8P
1
120
RP21
0141-2209-3851
ARRAY RES. A(X) 22ohm 4R J 8P
1
121
RP22
0141-2209-3851
ARRAY RES. A(X) 22ohm 4R J 8P
1
122
RP9
0141-0000-3851
ARRAY RES. A(X) 0.0ohm 4R J 8P
1
123
R11
0130-0000-0055
RES. CF 0.0ohm 1/10W J 0603
1
124
R111
0130-1009-0055
RES. CF 10ohm 1/10W J 0603
1
125
R112
0130-1009-0055
RES. CF 10ohm 1/10W J 0603
1
126
R113
0130-1009-0055
RES. CF 10ohm 1/10W J 0603
1
127
R114
0130-4708-0055
RES. CF 4.7ohm1/10W J 0603
1
128
R117
0130-1000-0055
RES. CF 100ohm 1/10W J 0603
1
129
R118
0130-1000-0055
RES. CF 100ohm 1/10W J 0603
1
CONFIDENTIAL – DO NOT COPY
Page 11-16
File No. SG-0159
ITEM
M/S
LOCATION
PART NO.
DESCRPTION
QTY
130
R119
0130-1002-0055
RES. CF 10Kohm 1/10W J 0603
1
131
R120
0130-1002-0055
RES. CF 10Kohm 1/10W J 0603
1
132
R121
0130-5100-0055
RES. CF 510ohm 1/10W J 0603
1
133
R122
0130-1000-0055
RES. CF 100ohm 1/10W J 0603
1
134
R123
0130-0000-0055
RES. CF 0.0ohm 1/10W J 0603
1
135
R124
0130-4701-0055
RES. CF 4.7Kohm 1/10W J 0603
1
136
R125
0130-1001-0055
RES. CF 1.0Kohm 1/10W J 0603
1
137
R126
0130-0000-0055
RES. CF 0.0ohm 1/10W J 0603
1
138
R127
0130-1002-0055
RES. CF 10Kohm 1/10W J 0603
1
139
R128
0130-0000-0055
RES. CF 0.0ohm 1/10W J 0603
1
140
R129
0130-1002-0055
RES. CF 10Kohm 1/10W J 0603
1
141
R131
0130-0000-0055
RES. CF 0.0ohm 1/10W J 0603
1
142
R136
0130-4701-0055
RES. CF 4.7Kohm 1/10W J 0603
1
143
R137
0130-4701-0055
RES. CF 4.7Kohm 1/10W J 0603
1
144
R141
0130-0000-0055
RES. CF 0.0ohm 1/10W J 0603
1
145
R142
0130-1003-0055
RES. CF 100Kohm 1/10W J 0603
1
146
R143
0130-0000-0055
RES. CF 0.0ohm 1/10W J 0603
1
147
R145
0130-1003-0055
RES. CF 100Kohm 1/10W J 0603
1
148
R146
0130-0000-0055
RES. CF 0.0ohm 1/10W J 0603
1
149
R147
0130-0000-1859
RES. CF 0.0ohm 1/4W J 1206
1
150
R148
0111-3103-5116
C/M MULTI 0.01UF 50V X7R 0603
1
151
R149
0111-3103-5116
C/M MULTI 0.01UF 50V X7R 0603
1
152
R150
0130-0000-0055
RES. CF 0.0ohm 1/10W J 0603
1
153
R152
0130-1000-1858
RES. CF 100ohm 1/8W J 0805
1
154
R155
0130-1002-0055
RES. CF 10Kohm 1/10W J 0603
1
155
R23
0130-1002-0055
RES. CF 10Kohm 1/10W J 0603
1
156
R24
0130-1001-0055
RES. CF 1.0Kohm 1/10W J 0603
1
157
R25
0130-1004-0055
RES. CF 1.0Mohm 1/10W J 0603
1
158
R34
0130-0000-0055
RES. CF 0.0ohm 1/10W J 0603
1
159
R35
0130-4709-0055
RES. CF 47ohm 1/10W J 0603
1
160
R36
0130-4709-0055
RES. CF 47ohm 1/10W J 0603
1
161
R37
0130-4709-0055
RES. CF 47ohm 1/10W J 0603
1
162
R38
0130-4709-0055
RES. CF 47ohm 1/10W J 0603
1
CONFIDENTIAL – DO NOT COPY
Page 11-17
File No. SG-0159
ITEM
M/S
LOCATION
PART NO.
DESCRPTION
QTY
163
R39
0130-4709-0055
RES. CF 47ohm 1/10W J 0603
1
164
R4
0131-6049-0015
RES MF 60.4ohm 1/10W F 0603
1
165
R40
0130-4709-0055
RES. CF 47ohm 1/10W J 0603
1
166
R41
0130-1002-0055
RES. CF 10Kohm 1/10W J 0603
1
167
R42
0130-1002-0055
RES. CF 10Kohm 1/10W J 0603
1
168
R43
0130-1004-0055
RES. CF 1.0Mohm 1/10W J 0603
1
169
R45
0130-1001-0055
RES. CF 1.0Kohm 1/10W J 0603
1
170
R46
0130-0000-0055
RES. CF 0.0ohm 1/10W J 0603
1
171
R47
0130-8201-0055
RES. CF 8.2Kohm 1/10W J 0603
1
172
R51
0130-0000-0055
RES. CF 0.0ohm 1/10W J 0603
1
173
R55
0130-2209-0055
RES. CF 22ohm 1/10W J 0603
1
174
R56
0130-2209-0055
RES. CF 22ohm 1/10W J 0603
1
175
R57
0130-2209-0055
RES. CF 22ohm 1/10W J 0603
1
176
R6
0130-1000-0055
RES. CF 100ohm 1/10W J 0603
1
177
R61
0130-1001-0055
RES. CF 1.0Kohm 1/10W J 0603
1
178
R62
0130-8201-0055
RES. CF 8.2Kohm 1/10W J 0603
1
179
R63
0130-1000-0055
RES. CF 100ohm 1/10W J 0603
1
180
R64
0130-1000-0055
RES. CF 100ohm 1/10W J 0603
1
181
R65
0130-1000-0055
RES. CF 100ohm 1/10W J 0603
1
182
R66
0130-1000-0055
RES. CF 100ohm 1/10W J 0603
1
183
R67
0130-1000-0055
RES. CF 100ohm 1/10W J 0603
1
184
R68
0130-1001-0055
RES. CF 1.0Kohm 1/10W J 0603
1
185
R69
0130-1001-0055
RES. CF 1.0Kohm 1/10W J 0603
1
186
R84
0130-1002-0055
RES. CF 10Kohm 1/10W J 0603
1
187
R85
0130-4702-0055
RES. CF 47Kohm 1/10W J 0603
1
188
R86
0130-1003-0055
RES. CF 100Kohm 1/10W J 0603
1
189
R87
0130-2700-0055
RES. CF 270ohm 1/10W J 0603
1
190
R88
0130-1000-0055
RES. CF 100ohm 1/10W J 0603
1
191
R90
0130-0000-0055
RES. CF 0.0ohm 1/10W J 0603
1
192
R93
0130-4701-0055
RES. CF 4.7Kohm 1/10W J 0603
1
193
R94
0130-4701-0055
RES. CF 4.7Kohm 1/10W J 0603
1
194
U10
0430-7024-1738
IC SiI1161CT100 TQFP100
1
195
U11
0430-3001-1011
IC AT24C02N-10SI-2.7 SMD 8PIN
1
CONFIDENTIAL – DO NOT COPY
Page 11-18
File No. SG-0159
ITEM
196
M/S
LOCATION
SS
PART NO.
DESCRPTION
0430-3000-5017
IC 24LC02B/SN SMD 8PIN
QTY
197
U15
0430-5011-4788
IC ispMACH4128V 100P TQFP
1
198
U2
0430-6005-6004
IC LM1117MPX-ADJ SMD 3PIN (SOT-223)
1
199
U5
0430-5007-5578
IC SM5964C40J 44PIN PLCC
1
200
U5S
0204-1274-4012
PLCC SOCKET 44PIN SMD
1
201
U7
0430-8001-0804
IC DS90C387 SMD 100PIN (MQFP)
1
0430-7024-1799
IC EP-387A 100PIN (TQFP)
202
SS
203
W4
0302-2000-0306
CONN MALE R/A 30P SMD (MS240430)
1
204
ZD1
0400-0491-5012
ZENER
4.98~5.20V UDZSTE-175.1B 1/5W SOD-323 L-F
1
205
ZD10
0400-0491-5012
ZENER
4.98~5.20V UDZSTE-175.1B 1/5W SOD-323 L-F
1
206
ZD11
0400-0491-5012
ZENER
4.98~5.20V UDZSTE-175.1B 1/5W SOD-323 L-F
1
207
ZD12
0400-0491-5012
ZENER
4.98~5.20V UDZSTE-175.1B 1/5W SOD-323 L-F
1
208
ZD13
0400-0491-5012
ZENER
4.98~5.20V UDZSTE-175.1B 1/5W SOD-323 L-F
1
209
ZD2
0400-0491-5012
ZENER
4.98~5.20V UDZSTE-175.1B 1/5W SOD-323 L-F
1
210
ZD3
0400-0491-5012
ZENER
4.98~5.20V UDZSTE-175.1B 1/5W SOD-323 L-F
1
211
ZD4
0400-0491-5012
ZENER
4.98~5.20V UDZSTE-175.1B 1/5W SOD-323 L-F
1
212
ZD5
0400-0491-5012
ZENER
4.98~5.20V UDZSTE-175.1B 1/5W SOD-323 L-F
1
213
ZD7
0400-0721-5012
ZENER
7.28~7.60V UDZSTE-177.5B 1/5W SOD-323 L-F
1
214
ZD8
0400-0491-5012
ZENER
4.98~5.20V UDZSTE-175.1B 1/5W SOD-323 L-F
1
215
ZD9
0400-0491-5012
ZENER
4.98~5.20V UDZSTE-175.1B 1/5W SOD-323 L-F
1
CONFIDENTIAL – DO NOT COPY
Page 11-19
File No. SG-0159
3842-0032-0189M
ITEM
M/S
PDP IR BD ASS'Y (PD-42S) MI
LOCATION
PART NO.
DESCRPTION
1
DR1
0440-5000-0170
LED L3-WSURKPBW B/R DIP 3
2
DR1-H
1701-1500-0940
LED HOLDER (QLE-3)
3
DR5
0440-1000-0050
LED L-934ID-F01 3
4
DR5-H
1701-1500-0950
LED HOLDER (LED3-3)
1
5
UR1
0980-0200-2130
MODULE. IR RECEIVER (FM-6038LM-5AN)
1
6
WR1
0451-2000-0566
WAFER 2.00MM 5P 90' KINK (STM)
1
CONFIDENTIAL – DO NOT COPY
ψ
φ
QTY
1
1
RED
1
Page 11-20
File No. SG-0159
3842-0032-0189S
ITEM
M/S
PDP IR BD ASS'Y (PD-42S) SMD
LOCATION
1
PART NO.
DESCRPTION
QTY
0171-1641-0222
PCB IR BD FR4 45.0*22.0*1.6t D (PD-42S)
1
2
CR2
0112-3104-5116
C/M Muitl. 0.1uF 50V X7R 0603
1
3
CR3
0112-3104-5116
C/M Muitl. 0.1uF 50V X7R 0603
1
4
CR4
0111-3475-1135
C/M MULTI 4.7uF 10V Y5V 0805
1
5
LR1
0370-0000-6452
CHIP BEAD CORE 80ohm (MLB-201209-0080A-N2)
1
6
QR1
0410-5000-1610
TRANSISTOR MMBT3904LT1 SMD T
1
0410-5000-1604
TRANSISTOR 2N3904 SMD T
0410-5000-2610
TRANSISTOR MMBT3906LT1 SMD
0410-5000-2604
TRANSISTOR MMBT3906 SMD (SOT-23)
0410-5000-1610
TRANSISTOR MMBT3904LT1 SMD T
0410-5000-1604
TRANSISTOR 2N3904 SMD T
7
CS
8
9
QR2
CS
10
11
QR3
CS
1
1
12
RR1
0130-4709-0055
RES. CF 47ohm 1/10W J 0603
1
13
RR10
0130-4709-0055
RES. CF 47ohm 1/10W J 0603
1
14
RR13
0130-3301-0055
RES. CF 3.3Kohm 1/10W J 0603
1
15
RR17
0130-4700-0055
RES. CF 470ohm 1/10W J 0603
1
16
RR2
0130-4709-0055
RES. CF 47ohm 1/10W J 0603
1
17
RR4
0130-3301-0055
RES. CF 3.3Kohm 1/10W J 0603
1
18
RR5
0130-4700-0055
RES. CF 470ohm 1/10W J 0603
1
19
RR6
0130-3301-0055
RES. CF 3.3Kohm 1/10W J 0603
1
20
RR7
0130-3301-0055
RES. CF 3.3Kohm 1/10W J 0603
1
21
RR8
0130-3301-0055
RES. CF 3.3Kohm 1/10W J 0603
1
22
UR2
0430-1004-7035
IC NC7SZ14M5 5PIN SOT-23
1
23
ZDR1
0400-0491-5012
ZENER
4.98~5.20V UDZSTE-175.1B 1/5W SOD-323 L-F
1
24
ZDR2
0400-0491-5012
ZENER
4.98~5.20V UDZSTE-175.1B 1/5W SOD-323 L-F
1
25
ZDR3
0400-0491-5012
ZENER
4.98~5.20V UDZSTE-175.1B 1/5W SOD-323 L-F
1
CONFIDENTIAL – DO NOT COPY
Page 11-21
File No. SG-0159
4
U1
LM2575-ADJ
4
2
L1
5V_uP
100uH_1A(DIP)
5V_uP
D1
SB560
R3
6.12K
R5
0
+
C3
1000uF/16V
PW_POMUTE (2)
PW_SW
(2)
N.C W250-7pin,180''
C4
0.1uF
V33_uP
U2
SPX1117-ADJ
3
IN
OUT
C6
C5
470uF/16V0.1uF
2
+
R11
R14
R15
0
N.C 0
RELAY_ON (2)
BK_LIGHT (2)
PWM_P
(2)
1
VIN
5
CTL
R10
N.C 0
C10
C9
N.C 0.1uF
N.C 1000uF/25V/LOW ESR
C8
D
100uF/16V
FBK
4
OPT
2
R8
N.C 0/0603
SW-V120
L2
N.C 100uH_1A(DIP)
D2
N.C SB560
R12
N.C 0
R13
N.C 10K
+
N.C 10K
C12
N.C 0.1uF
C11
N.C 1000uF/16V
C
C13
N.C 10uF/16V
R16
FUSE
1
2
3
4
5
6
F1
+
R19
C16
N.C 0
N.C 0.1uF
C14
N.C 1000uF/25V/LOW ESR
1
VIN
5
CTL
GND
SW-V180
A18V
J2
N.C 1.2K
U4
N.C LM2576-ADJ
FBK
4
OPT
2
R17
N.C 0
SW-V50
L3
3
2
W250-8pin,180''
1
C
N.C F1001
GND
FUSE
1
2
3
4
5
6
7
8
3
A18V
W1
U3
N.C LM2575-ADJ
SW-V180
0.1uF
100
2K
N.C 0/1206
C7
60.4/0603
R6
R7
R9
R4
1
R2
0
C2
0.1uF
C1
N.C 1000uF/25V/LOW ESR
FBK
OPT
2
CTL
ADJ
POWER_ON (2)
VIN
5
R1
N.C 0
3
+
1
2
3
4
5
6
7
D
1
1
1
J1
2
1
A18V1
GND
A18V
3
2
5
N.C 100uH_3A(DIP)
D3
N.C SB560
R21
NC 0
R20
N.C 6.12K
+
C17
N.C 0.1uF
C15
N.C 1000uF/16V
W250-6pin,180''
B
B
R22
Q1
A18V1
0/1206
MOS_S
L5
N.C 2K
SW-V180
P2003EV
1
2
3
0/1206
N.C AOD-405
MOS_S 2
3
MOS_D
G
4
R23
10K
Q15
MOS_D
5
6
7
8
NOTE : NC MEANS "NOT CONNECTED ON PCB BOARD"
ALL RESISTORS 1/10 WATT,5% UNLESS NOTED.
ALL RESISTORS VALUES IN OHMS UNLESS NOTED.
ALL CAPACITORS 50 VOLT & 105"C UNLESS NOTED.
ALL CAPACITOR VALUES IN uF UNLESS NOTED.
ALL RESISTORS 25 VOLT IN .1uF UNLESS NOTED.
M= METAL 1%
1
L4
MOS_G
MOS_G
L6
0/1206
+
C18
R24
1K
(2)
R149
0/1206
5
SW_ON
R25
Q2
2N7002
1M
A
2
R26
1
A
N.C 1N4148
N.C 10K
C86
AmTRAN
1
D21
2
0/1206
3
N.C 470uF/25V
R148
TECHNOLOGY
47uF/16V
4
3
2
MODEL
PD-42S (3842-0012-0154)
CIRCUITY
POWER
CHECKED BY:
PCB P/ N: 0171-2141-0062
ECN NO: APCN04090017
APPROVED BY:
SCH FILE : PD42S-C2.DSN
PCB FILE : PD42S-M2.PCB
1
Sheet
1
of
REV:
02
PCB REV:
02
8
DATE: Friday, October 15, 2004
5
4
3
2
1
D
D
W1
1
2
3
4
5
6
7
C
C
W200-7
SWK1
SWK2
SWK3
SWK4
SWK5
SWK6
VOL-
VOL+
CH-
CH+
SOURCE
POWER
B
B
NOTE : NC MEANS "NOT CONNECTED ON PCB BOARD"
ALL RESISTORS 1/10 WATT,5% UNLESS NOTED.
ALL RESISTORS VALUES IN OHMS UNLESS NOTED.
ALL CAPACITORS 50 VOLT & 105"C UNLESS NOTED.
ALL CAPACITOR VALUES IN uF UNLESS NOTED.
ALL RESISTORS 25 VOLT IN .1uF UNLESS NOTED.
M= METAL 1%
AmTRAN
A
TECHNOLOGY
CHECKED BY:
4
3
PD42S (3842-0022-0156)
CIRCUITY
KEYPAD
A
PCB P/ N: 0170-1740-1181
Sheet
ECN NO:
REV:
02
PCB REV:
01
APCN04090017
SCH FILE : PD42S-C2.DSN
PCB FILE : PD42S-D1.PCB
APPROVED BY:
5
MODEL
2
1
of
1
DATE: Friday, October 15, 2004
1
5
4
3
2
1
V50
CR2
0.1uF/0603
D
V50
RR10
UR1
FM-6038LM-5A
47
3
VCC
VO
V50
1
UR2
2
CR4
GND
D
4.7uF/0805
RR1
47/0603
1
NC VCC
2
A
3
GND
Y
5
RR2
4
47/0603
7SZ14
RR3
1
C
QR1
2N3904-SOT23
3
NC 0/0603
V50
C
DR1
LR1
2
470/0603
1 RR5
470/0603
LED1
3
1
3 RR11
470/0603
1 RR12
470/0603
3
RR14
470/0603
1
RR15
470/0603
2
DR2
2
IR
2
3 RR4
80/0805
LED2
QR2
2N3906
RR7
3.3K/0603
CR3
RR8
0.1uF/0603 3.3K/0603
QR3
ZDR3
2
1
N.C LED3
2N3904-SOT23
B
RR17
DR5
2
2
N.C LED1
UDZS 5.1B
UDZS 5.1B
B
470/0603
WR2
DR6
LED1
LED1
2
1
2
1
N.C W200-2
NOTE : NC MEANS "NOT CONNECTED ON PCB BOARD"
ALL RESISTORS 1/10 WATT,5% UNLESS NOTED.
ALL RESISTORS VALUES IN OHMS UNLESS NOTED.
ALL CAPACITORS 50 VOLT & 105"C UNLESS NOTED.
ALL CAPACITOR VALUES IN uF UNLESS NOTED.
ALL RESISTORS 25 VOLT IN .1uF UNLESS NOTED.
M= METAL 1%
2
DR4
UDZS 5.1B
RR9
470/0603
1
1
470/0603
1
RR16
ZDR2
RR13
3.3K/0603
3
2
RR6
3.3K/0603
1
2
3
4
5
W200-5
ZDR1
DR3
WR1
A
A
AmTRAN
TECHNOLOGY
5
4
3
2
MODEL
PD-42S (3842-0032-0189)
CIRCUITY
IR
CHECKED BY:
PCB P/ N: 0171-1641-0222
ECN NO: APCN04090017
APPROVED BY:
SCH FILE : PD42S-C2.DSN
PCB FILE : PD42S-IR2.PCB
1
Sheet
1
of
REV:
02
PCB REV:
02
1
DATE: Friday, October 15, 2004
5
4
2
2
1
5V_uP
LED1
Q3
3 2
N.C 2N3904-SOT23
1
3
1 R31
N.C 470
U4是PLCC 44 type, 要有 U4S
SMD 的 Socket
R138
N.C 4.7K
N.C LED1
R134
R135
R136
N.C 4.7K N.C 4.7K 4.7K
R137
4.7K
R27
R28
R29
N.C 0
N.C 0
N.C 0
N.C R30
N.C R32
0
0
R34
0
POWER_ON (1)
PW_POMUTE (1)
PW_SW
(1)
BK_LIGHT (1)
PWM_P
(1)
FOR NEC
Plasma Panel
FOR CMO LCD
Panel
U5
D
R33
(6)
(6)
(3)
(3)
(7)
N.C 1K
LED1
LED2
47
47
47
47
R35
R36
R37
R38
SCLK
SDATA
PDP_SCLK
PDP_SDATA
DVI_HotPlug
C19
C20
N.C 0.1uFN.C 0.1uF
KPD0
KPD1
KPD2
KPD3
KPD4
KPD5
KPD6
PW RON
C
Y1
1
2
SB140
5V_uP
P1.0
P1.1
P1.2
P1.3
P1.4
P1.5
P1.6
P1.7
23
34
1
12
TP1
D22
P2.0/A8
P2.1/A9
P2.2/A10
P2.3/A11
P2.4/A12
P2.5/A13
P2.6/A14
P2.7/A15
24
25
26
27
28
29
30
31
P3.0/RxD
P3.1/TxD
P3.2/INT0
P3.3/INT1
P3.4/T0
P3.5/T1
P3.6WR
P3.7RD
11
13
14
15
16
17
18
19
P0.0/AD0
P0.1/AD1
P0.2/AD2
P0.3/AD3
P0.4/AD4
P0.5/AD5
P0.6/AD6
P0.7/AD7
2
3
4
5
6
7
8
9
(8) CPLD_EN
(8) CPLD_ByPass
(7) EEPROM_EN
5V_uP
43
42
41
40
39
38
37
36
P4.0
P4.1
P4.2/INT3
P4.3/INT2
20
21
XTAL2
XTAL1
44
VDD
C21
PSEN
32
ALE
33
RST
EA
10
35
VSS
22
BLKH
(3)
SW_ON
(1)
LE
(3)
LVDS_387_PD (3)
MUTE
(5)
R39
R40
CTL_MODE1
CTL_MODE2
5V_uP
1K
LED2
5V_uP
1M
C23
C24
15pF
15pF
N.C 1K
U6
5V_uP
R48
N.C 1K 2
R46
R49
N.C 100
RP2
1K
B
R50
N.C 1K
0
R52
N.C 470 2
(3,7,8)
BAV99
5
3
D5
D6
D7
3
3
3
BAV99
BAV99
1
N.C 2N3904-SOT23
2
D4
3
BAV99
BAV99
Q5
NOTE : NC MEANS "NOT CONNECTED ON PCB BOARD"
ALL RESISTORS 1/10 WATT,5% UNLESS NOTED.
ALL RESISTORS VALUES IN OHMS UNLESS NOTED.
ALL CAPACITORS 50 VOLT & 105"C UNLESS NOTED.
ALL CAPACITOR VALUES IN uF UNLESS NOTED.
ALL RESISTORS 25 VOLT IN .1uF UNLESS NOTED.
M= METAL 1%
BAV99
A
AmTRAN
1
3
1
BAV99
1
1
BAV99
3
CP2
0.01uF
1
3
A
CP1
0.01uF
D11
1
D10
5V_uP
DVS
1
D9
2
2
2
2
D8
5V_uP
2
5V_uP
2
5V_uP
5V_uP
1
5V_uP
2
5V_uP
DVS_D
3
R51
W200-9R
5V_uP
8.2K
5V_uP
9
8
7
6
5
4
3
2
1
KPD3
KPD4
KPD5
KPD6
R47
N.C 2N3904-SOT23
W3
KPD0
KPD1
KPD2
+ C22
10u/1206
0
Q4
1
5V_uP
RP1
1K
TECHNOLOGY
4
C
RESET_uP
N.C MAX809
2
1
W200-6A
PWRON
KPD[6:0]
2
4
5V_uP
3
GND
PWRON
B
JP1
1
3
R44
3
(4)
10K CTL_MODE1
10K CTL_MODE2
HDR_2X2/2.54mm
5V_uP
VCC
R45
IR
R41
R42
5V_uP
W78LE51P
RSTN
IR
LED1
RxD
(4)
TxD
(4)
ALARM
(3)
DHS_D
(3)
DB15_HotPlug (4)
DVI_ON (7)
DVS_D
R43
1
2
3
4
5
6
47
47
D
FOR SAMSUNG
Plasma
Panel
0.1uF
24MHz
W2
RELAY_ON (1)
3
2
MODEL
PD-42S (3842-0012-0154)
CIRCUITY
POWER
CHECKED BY:
PCB P/ N: 0171-2141-0062
ECN NO: APCN04090017
APPROVED BY:
SCH FILE : PD42S-C2.DSN
PCB FILE : PD42S-M2.PCB
1
Sheet
2
of
REV:
02
PCB REV:
02
8
DATE: Friday, October 15, 2004
5
4
3
2
1
V33_uP
RP8
G16
G17
G10
G11
G12
G13
G14
G15
86
85
92
91
90
89
88
87
B16
B17
B10
B11
B12
B13
B14
B15
76
75
84
81
80
79
78
77
R26
R27
R20
R21
R22
R23
R24
R25
66
65
74
73
72
71
70
69
G26
G27
G20
G21
G22
G23
G24
G25
58
57
64
63
62
61
60
59
B26
B27
B20
B21
B22
B23
B24
B25
22
PD
14
15
20
21
23
24
PRE
PLLSEL
R_FB
R_FDE
DUAL
BAL
DBE0
DBE1
DBE2
DBE3
DBE4
DBE5
DBE6
DBE7
C
RRE6 0
RRE7
RRE0
RRE1
RRE2 0
RRE3
RRE4
RRE5
FOR CMO
SAMSUNG
RP9
RP10
RGE6 0
RGE7
RGE0
RGE1
RGE2 0
RGE3
RGE4
RGE5
RP11
RBE6 0
RBE7
RBE0
RBE1
RBE2 0
RBE3
RBE4
RBE5
RP13
RP12
RP14
DRE0
DRE1
DRE2
DRE3
DRE4
DRE5
DRE6
DRE7
DGE0
DGE1
DGE2
DGE3
DGE4
DGE5
DGE6
DGE7
(2)
(2)
(2)
DBE0
DBE1
DBE2
DBE3
DBE4
DBE5
DBE6
DBE7
LE
PDP_SCLK
PDP_SDATA
C38
N.C 15pF
C39
N.C 15pF
(2) LVDS_387_PD
V33_uP
B
R58
V33_uP
R60
DUAL
N.C 1K
R61
53
67
82
97
C29
C30
C31
C32
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
SW-V120
V33_uP V33_uP V33_uP V33_uP V33_uP
A0
A0
49
50
RA+
RA-
A1
A1
46
47
RB+
RB-
A2
A2
44
45
RC+
RC-
A3
A3
38
39
RD+
RD-
CLK1
CLK1
41
42
RCLK+
RCLK-
A4
A4
36
37
RE+
RE-
A5
A5
33
34
RF+
RF-
A6
A6
31
32
RG+
RG-
A7
A7
28
29
RH+
RH-
CLK2
CLK2
26
27
U7
DS90C387
L7
N.C 0/1206
L8
N.C 0/1206
(2)
L10 0/1206
2
C34
C35
C36
C37
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
C
W4
1
30
29
28
27
26
25
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
RARA+
RBRB+
RCRC+
RCLKRCLK+
RDRD+
RERE+
ALARM
C33
L9
N.C 0/1206
RFRF+
RGRG+
RHRH+
13
16
17
19
DUAL
N.C 4.7K
SW-V50
C28
2
94
93
2
1
100
99
96
95
VCC1
VCC2
VCC3
VCC4
DGE0
DGE1
DGE2
DGE3
DGE4
DGE5
DGE6
DGE7
PVCC1
PVCC2
R16
R17
R10
R11
R12
R13
R14
R15
LVCC1
LVCC2
LVCC3
12
18
DBE0
DBE1
DBE2
DBE3
DBE4
DBE5
DBE6
DBE7
4
3
10
9
8
7
6
5
D
1
RP7
DGE0
DGE1
DGE2
DGE3
DGE4
DGE5
DGE6
DGE7
DRE0
DRE1
DRE2
DRE3
DRE4
DRE5
DRE6
DRE7
0.1uF
2
RBE0 N.C 0
RBE1
RBE2
RBE3
RBE4 N.C 0
RBE5
RBE6
RBE7
RP6
N.C 22
N.C 22
0/0603
C27
0.1uF
1
RP5
R139
R140
R150
C26
V33_uP V33_uP V33_uP V33_uP V33_uP
2
RGE0 N.C 0
RGE1
RGE2
RGE3
RGE4 N.C 0
RGE5
RGE6
RGE7
(2,7,8) DVS
(7,8) DHS
(2) DHS_D
22
22
22
CLKIN
DE
VSYNC
HSYNC
1
(7) RBE[7:0]
RP4
DRE0
DRE1
DRE2
DRE3
DRE4
DRE5
DRE6
DRE7
R55
R56
R57
11
56
55
54
R151
N.C 0/0603
B
DF14A-30P-1.25H
GND1
GND3
GND3
GND4
(7) RGE[7:0]
RP3
N.C 22
V33_uP V33_uP
+ C25
10u/1206
R59
N.C 10K
52
68
83
98
RRE0 N.C 0
RRE1
RRE2
RRE3
RRE4 N.C 0
RRE5
RRE6
RRE7
R54
LGND1
LGND2
LGND3
LGND4
(7) RRE[7:0]
N.C 22
25
35
43
51
FOR LG , NEC PDP
D
DCLK
DEN
DVS_Out
DHS_Out
R53
PGND1
PGND2
PGND3
PGND4
(7,8)
(7,8)
(8)
(8)
BLKH
30
40
48
V33_uP
(2)
1K
LVDS Output Header
LVDS Transmitter
NOTE : NC MEANS "NOT CONNECTED ON PCB BOARD"
ALL RESISTORS 1/10 WATT,5% UNLESS NOTED.
ALL RESISTORS VALUES IN OHMS UNLESS NOTED.
ALL CAPACITORS 50 VOLT & 105"C UNLESS NOTED.
ALL CAPACITOR VALUES IN uF UNLESS NOTED.
ALL RESISTORS 25 VOLT IN .1uF UNLESS NOTED.
M= METAL 1%
A
A
AmTRAN
TECHNOLOGY
CHECKED BY:
APPROVED BY:
5
4
3
2
MODEL
PD-42S (3842-0012-0154)
CIRCUITY
LVDS_TR
PCB P/ N: 0171-2141-0062
ECN NO:
APCN04090017
SCH FILE : PD42S-C2.DSN
PCB FILE : PD42S-M2.PCB
1
Sheet
3
of
REV:
02
PCB REV:
02
8
DATE: Friday, October 15, 2004
5
4
3
2
1
D
D
ZD1
UDZS 5.1B
C40
ZD2
100pF
UDZS 5.1B
C41
100pF
W5
(2)
R63
IR
5V_uP
(2) DB15_HotPlug
5V_uP
C
(2)
(2)
(5)
RxD
TxD
Audio_L
100
R62
1
2
3
4
5
6
7
8
9
10
8.2K
R141
0
R65
R66
R67
100
100
100
R64
11
12
13
14
15
16
17
18
19
20
R68
1K
100
Audio_R
V33_uP
5V_uP
SDO/TDO (8)
SDI/TDI
(8)
MODE/TMS (8)
5V_uP
SCLK/TCK (8)
ZD5
C43
100pF
UDZS 5.1B
ZD8
C45
100pF
UDZS 5.1B
C87
100pF
ZD9
UDZS 5.1B
ZD10
UDZS 5.1B
ZD11
UDZS 5.1B
ZD13
UDZS 5.1B
UDZS 5.1B
R71
ZD6
N.C UDZS 5.1B
ZD4
C42
C44
100pF
100pF
ZD12
R69
C
R70
N.C 47K
CON20B
ZD3
(5)
N.C 100
Q6
N.C BC847
Audio_C
C46
N.C 100pF
R72
N.C 22K
(5)
R73
N.C 470
1K
UDZS5.1B
UDZS 5.1B
B
B
NOTE : NC MEANS "NOT CONNECTED ON PCB BOARD"
ALL RESISTORS 1/10 WATT,5% UNLESS NOTED.
ALL RESISTORS VALUES IN OHMS UNLESS NOTED.
ALL CAPACITORS 50 VOLT & 105"C UNLESS NOTED.
ALL CAPACITOR VALUES IN uF UNLESS NOTED.
ALL RESISTORS 25 VOLT IN .1uF UNLESS NOTED.
M= METAL 1%
A
A
AmTRAN
TECHNOLOGY
5
4
3
2
MODEL
PD-42S (3842-0012-0154)
CIRCUITY
D-TYPE
CHECKED BY:
PCB P/ N: 0171-2141-0062
ECN NO: APCN04090017
APPROVED BY:
SCH FILE : PD42S-C2.DSN
PCB FILE : PD42S-M2.PCB
1
Sheet
4
of
REV:
02
PCB REV:
02
8
DATE: Friday, October 15, 2004
5
4
3
5V_uP
(4)
1
5V_uP
R74
N.C 47K
D
2
R75
N.C 47K
Q7
N.C BC847
Audio_R
(4)
2 R76
1
C47
R79
N.C 470
R78
N.C 22K
N.C 1K
Q8
N.C BC847
Audio_L
D
C48
1
Audio_RL
N.C 47uF/16V
R80
N.C 22K
R81
N.C 470
R77
2
N.C 1K
Audio_RL
N.C 47uF/16V
SW-V180
width 120 mil
C49
(4)
C88
0.47uF/0805
R146
0/0603
R82
N.C 0
R83
N.C 0
8
IN1+
6
IN2+
0/0603
C52
R145
100K
R143
N.C 0/0603
Audio_L
C
U8
N.C 0.22uF/0805
Audio_RL
R85
100K
R87
J3
RL+
12
0.47uF/0805
C54
22uF/25V
13
IN4+
OUT4+
CIV
OUT3-
11
2.2uF/25V
14
2
2
C57
220uF/25V
Q10
2N7002
2
MOD2
1
2
Speaker L
C55 W250-2pin,180''
N.C 470uF/25V
SGND
10
MODE1
5
MODE2
15
2
C58
Speaker R
J4
1
2
2
7
1
2
N.C W250-2pin,180''
RLSUBWF+
SUBWF-
J5
GND2
1
1
C56
1
2
17
SVR
GND1
MUTE
100
IN3+
2
1
1
(2)
R88
Q9
2N3904
2
3
UDZS 7.5B
B
270
1N4148
1
4
3
ZD7
D12
2
1
7.5V
C53
R86
47K
OUT2-
2
R84
10K
Audio_C
1
R147 0/1206R
1
(4)
OUT1+
C
9
SW-V180
C50
N.C 1000uF/25V/LOW ESR
1
R144
N.C 0.22uF/0805
+
VCC2
R142
100K
C51
3
Audio_R
VCC1
(4)
16
0.1uF
2
1
B
SUBWFSUBWF+
W250-2pin,180''
TDA8947J
width 120 mil
R89
SW-V180
1UF
N.C 1.5K
R90
0
MOD2 R91
L11
0/0805
R152
0/0805
L12
0/0805
R153
0/0805
L13
0/0805
MOD2
N.C 0
NOTE : NC MEANS "NOT CONNECTED ON PCB BOARD"
ALL RESISTORS 1/10 WATT,5% UNLESS NOTED.
ALL RESISTORS VALUES IN OHMS UNLESS NOTED.
ALL CAPACITORS 50 VOLT & 105"C UNLESS NOTED.
ALL CAPACITOR VALUES IN uF UNLESS NOTED.
ALL RESISTORS 25 VOLT IN .1uF UNLESS NOTED.
M= METAL 1%
A
A
AmTRAN
TECHNOLOGY
5
4
3
2
MODEL
PD-42S (3842-0012-0154)
CIRCUITY
AMP
CHECKED BY:
PCB P/ N: 0171-2141-0062
ECN NO: APCN04090017
APPROVED BY:
SCH FILE : PD42S-C2.DSN
PCB FILE : PD42S-M2.PCB
1
Sheet
5
of
REV:
02
PCB REV:
02
8
DATE: Friday, October 15, 2004
5
4
3
2
1
V33_uP
V33_uP
D
R93
R94
R95
R96
4.7K
4.7K
N.C 4.7K
N.C 4.7K
R97
R98
SCLK
SDATA
C61
N.C 10K
V33_uP
D
I2C address
Hi=0x5Ch ,
Low=0x5Ah
C59
C60
N.C 0.1uF
N.C 10u/1206
U9
FANIN1
FANIN2
PWMOUT1
PWMOUT2
(2)
(2)
R92
PWMOUT1
1
2
3
4
5
6
7
8
N.C 47
N.C 47
FANIN1
FANIN2/GPIO0
PWMOUT1/ADDR_TRAP
PWMOUT2/GPIO1
FAN_FAULT#SMI#GPIO2
VOLT_FAULT#OVT#GPIO3
SCLK
SDATA
VCC
VT1
VT2
VREF
VIN1
VIN2
VIN3
GND
16
15
14
13
12
11
10
9
T1
T2
VREF
CN1
T1
VREF
3
2
1
T1
R132
N.C 10K 1%
R133
N.C 10K THERMISTOR
VREF
N.C 3pin,180''
N.C F75373S
C62
N.C 0.1uFN.C 0.1uF
C
C
SW-V120
R99
N.C 4.7K
R100
N.C 1K
2
CN2
D14
N.C PBSS5140T
3
SOT23
1
N.C 100
2
C63
2
3
R102
Q12
N.C 2N7002
N.C 10uF/16V
CN3
N.C 4.7K
N.C 3pin,180''
R103
N.C 27K
3
2
1
1
PWMOUT1
R101
1
N.C 1N4148
T2
VREF
3
2
1
2
Q11
1
FANIN1
R104
N.C 10K
N.C 3pin,180''
B
B
R106
N.C 1K
Q13
2
N.C 4.7K
2
SW-V120
R105
1
N.C PBSS5140T
1
Q14
N.C 2N7002
N.C 100
2
C64
2
3
R108
N.C 10uF/16V
1
PWMOUT2
D15
R107
N.C 1N4148
N.C 4.7K
NOTE : NC MEANS "NOT CONNECTED ON PCB BOARD"
ALL RESISTORS 1/10 WATT,5% UNLESS NOTED.
ALL RESISTORS VALUES IN OHMS UNLESS NOTED.
ALL CAPACITORS 50 VOLT & 105"C UNLESS NOTED.
ALL CAPACITOR VALUES IN uF UNLESS NOTED.
ALL RESISTORS 25 VOLT IN .1uF UNLESS NOTED.
M= METAL 1%
1
3
SOT23
CN4
R109
N.C 27K
3
2
1
FANIN2
R110
A
A
N.C 10K
N.C 3pin,180''
AmTRAN
TECHNOLOGY
5
4
3
2
MODEL
PD-42S (3842-0012-0154)
CIRCUITY
Fan
CHECKED BY:
PCB P/ N: 0171-2141-0062
ECN NO: APCN04090017
APPROVED BY:
SCH FILE : PD42S-C2.DSN
PCB FILE : PD42S-M2.PCB
1
Sheet
6
of
REV:
02
PCB REV:
02
8
DATE: Friday, October 15, 2004
5
4
3
ZD14
N.C UDZS 5.1B
ZD15
N.C UDZS 5.1B
ZD16
N.C UDZS 5.1B
ZD17
N.C UDZS 5.1B
2
1
D
D
CVCC
RP15
D16
U10
N.C 1N4148
VCCX
QO22
QO21
QO20
QO19
QO18
QO17
QO16
GND
VCC
QO15
QO14
QO13
QO12
QO11
QO10
QO9
QO8
OGND
OVCC
QO7
QO6
QO5
QO4
QO3
QO2
V33_uP
5V_uP
N.C 1N4148
C65
0.1uF
OVCC
W6
DVI
BAV99
D18
VCCX
2
(2)
8
7
6
5
EEPROM_EN
3
1
DVI_SCL
DVI_SDA
R117
R118
VCC
VCLK
SCL
SDA
100
100
NC
NC
NC
GND
1
2
3
4
AVCC
AVCC
24C02/SMD
AVCC
3
1
2
BAV99
1N4148
D20
R122
100
D19
VCCX
0
4.7K
VCCX
RP18
C66
47pF
R119
10K
47pF
R120
10K
AVCC
C67
RXR+
RXRRXC+
RXC-
AVCC
R121 510
PVCC
Sii1161_EP-387A
R123
CVCC
ZD18
N.C UDZS 5.1B
ZD19
N.C UDZS 5.1B
ZD21
N.C UDZS 5.1B
ZD22
N.C UDZS 5.1B
0
R124
OGND
QO23
OVCC
AGND
RX2+
RX2AVCC
AGND
AVCC
RX1+
RX1AGND
AVCC
AGND
RX0+
RX0AGND
RXC+
RXCAVCC
EXT_RES
PVCC
PGND
RESERVED
OCKINV
QO1
QO0
HS
VS
DE
OGND
ODCK
OVCC
CTL3
CTL2
CTL1
GND
VCC
QE23
QE22
QE21
QE20
QE19
QE18
QE17
QE16
OVCC
OGND
QE15
QE14
SiI161
50
49
48
47
46
45
44
43
42
41
40
39
38
37
36
35
34
33
32
31
30
29
28
27
26
R111
R112
R113
10
10
10
R114
4.7
R125
DVI_HotPlug (2)
1K
R115
R116
CVCC
ZD20
N.C UDZS 5.1B
R127
10K
RRE[7:0]
RP16 RR E7
RR E6
RR E5
RR E4
RP17 RR E3
RR E2
RR E1
RR E0
22
22
D VI_ON
DVI_ON
R128
22
CVCC
Sii1161_EP-387A
R129
10K
(3)
C
RP19 RGE7
RGE6
RGE5
RGE4
RP20 RGE3
RGE2
RGE1
RGE0
R126
0
CVCC
(3,8)
OVCC
OVCC
(2)
(3,8)
(2,3,8)
(3,8)
DCLK
CVCC
22
0
DHS
DVS
DEN
OVCC
N.C 0
N.C 0
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
C
U11
76
77
78
79
80
81
82
83
84
85
86
87
88
89
90
91
92
93
94
95
96
97
98
99
100
DFO
PD
ST
PIXS
GND
VCC
STAG_OUT
SCDT
PDO
QE0
QE1
QE2
QE3
QE4
QE5
QE6
QE7
OVCC
OGND
QE8
QE9
QE10
QE11
QE12
QE13
D17
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
C1
C2
C3
C4
C5
C6
OVCC
RXB+
RXBRXG+
RXG-
75
74
73
72
71
70
69
68
67
66
65
64
63
62
61
60
59
58
57
56
55
54
53
52
51
0
CVCC
22
R130
22
RP21 RBE7
RBE6
RBE5
RBE4
RP22 RBE3
RBE2
RBE1
RBE0
N.C 10K
RGE[7:0]
(3)
RBE[7:0]
(3)
V33_uP
B
B
AVCC
L14
2
CVCC
1
2
C70
47uF/16V
AVCC
1
2
2
80/0805
AVCC
PVCC
CVCC
CVCC
CVCC
OVCC
OVCC
OVCC
OVCC
OVCC
C84
47uF/16V
C71
C72
C73
C74
C75
C76
C77
C78
C79
C80
C81
C82
C83
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
1
2
2
A
AVCC
OVCC
L17
80/0805
AVCC
CVCC
L16
1
R156
2
80/0805
1
0/0603
C69
47uF/16V
PVCC
L15
1
R155Sii1161_EP-387A
N.C 0/0603
1
80/0805
C68
100uF/16V
2
2
1
1
R131
0
C85
47uF/16V
NOTE : NC MEANS "NOT CONNECTED ON PCB BOARD"
ALL RESISTORS 1/10 WATT,5% UNLESS NOTED.
ALL RESISTORS VALUES IN OHMS UNLESS NOTED.
ALL CAPACITORS 50 VOLT & 105"C UNLESS NOTED.
ALL CAPACITOR VALUES IN uF UNLESS NOTED.
ALL RESISTORS 25 VOLT IN .1uF UNLESS NOTED.
M= METAL 1%
A
AmTRAN
TECHNOLOGY
CHECKED BY:
APPROVED BY:
5
4
3
2
MODEL
PD-42S (3842-0012-0154)
CIRCUITY
Sil161
PCB P/ N: 0171-2141-0062
Sheet
APCN04090017
REV:
02
PCB REV:
02
ECN NO:
SCH FILE : PD42S-C2.DSN
PCB FILE : PD42S-M2.PCB
1
7
of
8
DATE: Friday, October 15, 2004
5
4
3
TP60
TP_DIP 1
TP61
TP_DIP 1
TP62
TP_DIP 1
TP63
TP_DIP 1
D
1
1
1
D
1
100
99
98
97
96
95
94
93
92
91
90
89
88
87
86
85
84
83
82
81
80
79
78
77
76
LC4064/128/256-T100_FULL
TP8
TP_DIP
TP9
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
SDI/TDI
TP_DIP
1
1
1
DHS
TP_DIP
C
DCLK
(2,3,7) DVS
TP13
LC4064/128/258-T100C
1
VCC
TDO
INPUT(B1)
I/O(B1)
I/O(B1)
I/O(B1)
I/O(B1)
GND(B1)
I/O(B1)
I/O(B1)
I/O(B1)
I/O(B1)
VCCO(B1)
INPUT(B1)
I/O(B1)
I/O(B1)
I/O(B1)
I/O(B1)
GND(B1)
I/O(B1)
I/O(B1)
I/O(B1)
I/O(B1)
TMS
GND
1
SDO/TDO
1
1
1
1
1
1
TP_DIP
TP43TP_DIP
TP42TP_DIP
TP41TP_DIP
TP40TP_DIP
TP39TP_DIP
C
TP38TP_DIP
TP37TP_DIP
TP_DIP
TP36
TP_DIP
TP35
1
TP_DIP
TP34
1
TP_DIP
TP33
1
MODE/TMS
TP_DIP
TP32
1
TP_DIP
TP31
1
TP_DIP
1
V33_uP
TP_DIP
1
TP12
75
74
73
72
71
70
69
68
67
66
65
64
63
62
61
60
59
58
57
56
55
54
53
52
51
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
1
SCLK/TCK
GND
TDI
I/O(B0)
I/O(B0)
I/O(B0)
I/O(B0)
GND(B0)
I/O(B0)
I/O(B0)
I/O(B0)
I/O(B0)
INPUT(B0)
VCCO(B0)
I/O(B0)
I/O(B0)
I/O(B0)
I/O(B0)
GND(B0)
I/O(B0)
I/O(B0)
I/O(B0)
I/O(B0)
INPUT(B0)
TCK
VCC
TP44
1
V33_uP
I/O(B0)
I/O(B0)
I/O(B0)
I/O(B0)
GND(B0)
VCCO(B0)
I/O(B0)
I/O(B0)
I/O(B0)
IO/GOE0(B0)
VCC
CLK0/INPUT(B0)
CLK3/INPUT(B1)
IO/GOE1(B1)
I/O(B1)
I/O(B1)
I/O(B1)
VCCO(B1)
GND(B1)
I/O(B1)
I/O(B1)
I/O(B1)
I/O(B1)
INPUT(B1)
GND
(2) CPLD_EN
(2) CPLD_ByPass
GND
INPUT(B0)
I/O(B0)
I/O(B0)
I/O(B0)
I/O(B0)
GND(B0)
VCCO(B0)
I/O(B0)
I/O(B0)
I/O(B0)
I/O(B0)
CLK1/INPUT(B0)
CLK2/INPUT(B1)
VCC
I/O(B1)
I/O(B1)
I/O(B1)
I/O(B1)
VCCO(B1)
GND(B1)
I/O(B1)
I/O(B1)
I/O(B1)
I/O(B1)
TP_DIP
1
TP5
TP48
1 TP_DIP
TP47
TP_DIP
TP46
1 TP_DIP
TP45
TP_DIP
1
V33_uP
U15
(3,7)
TP56
1 TP_DIP
TP55
TP_DIP
TP54
1 TP_DIP
TP53
1 TP_DIP
TP52
1 TP_DIP
TP51
1 TP_DIP
TP50
1 TP_DIP
TP49
TP_DIP
1
V33_uP
TP7
(3,7)
1
TP_DIP
1
TP4
TP57
TP_DIP 1
TP58
TP_DIP 1
TP59
TP_DIP 1
TP64
TP_DIP 1
TP65
TP_DIP 1
TP66
TP_DIP 1
TP67
TP_DIP 1
TP_DIP
1
TP3
TP6
TP2
TP_DIP TP_DIP
1
1
TP20
TP10
TP_DIP TP_DIP
2
TP11
B
1
TP_DIP
1
(3)
DVS_Out
TP14
1
1
TP_DIP
TP15
TP_DIP
1
1
TP16
TP_DIP
(3)
1
1
TP17
1
1
1
TP_DIP
DHS_Out
1
TP18
1
1
TP_DIP TP19
(3,7)
1
1
TP_DIP
DEN
TP23
TP24
TP28
TP29
TP30
B
TP_DIP
TP_DIP
TP27 TP_DIP
TP25 TP_DIP
V33_uP
SDO/TDO
SDI/TDI
(4) SDO/TDO
(4) SDI/TDI
TP_DIP
TP_DIP
MODE/TMS
G ND
SCLK/TCK
(4) MODE/TMS
TP22 TP_DIP
W7 PCB Footprint Error
V33_uP
TP26 TP_DIP
(4) SCLK/TCK
1
2
3
4
5
6
7
8
TP21 TP_DIP
N.C CON8
TP_DIP
V33_uP
V33_uP
V33_uP
V33_uP
V33_uP
V33_uP
V33_uP
V33_uP
V33_uP
V33_uP
C89
C90
C91
C92
C93
C94
C95
C96
C97
C98
0.1uF/0603C0.1uF/0603C0.1uF/0603C0.1uF/0603C0.1uF/0603C0.1uF/0603C0.1uF/0603C0.1uF/0603C0.1uF/0603C0.1uF/0603C
NOTE : NC MEANS "NOT CONNECTED ON PCB BOARD"
ALL RESISTORS 1/10 WATT,5% UNLESS NOTED.
ALL RESISTORS VALUES IN OHMS UNLESS NOTED.
ALL CAPACITORS 50 VOLT & 105"C UNLESS NOTED.
ALL CAPACITOR VALUES IN uF UNLESS NOTED.
ALL RESISTORS 25 VOLT IN .1uF UNLESS NOTED.
M= METAL 1%
A
A
AmTRAN
TECHNOLOGY
CHECKED BY:
APPROVED BY:
5
4
3
2
MODEL
PD-42S (3842-0012-0154)
CIRCUITY
CPLD
PCB P/ N: 0171-2141-0062
Sheet
APCN04090017
REV:
02
PCB REV:
02
ECN NO:
SCH FILE : PD42S-C2.DSN
PCB FILE : PD42S-M2.PCB
1
8
of
8
DATE: Friday, October 15, 2004
CAM350 V 7.6 : Thu Nov 25 15:46:19 2004 - (Untitled) : Board
CAM350 V 7.6 : Thu Nov 25 15:46:22 2004 - (Untitled) : TopSilk
CAM350 V 7.6 : Thu Nov 25 15:46:23 2004 - (Untitled) : Board