Download AOC 2236VWA Service manual
Transcript
21.5" LCD Color Monitor AOC e2236Vw Service Service Service Horizontal Frequency 30-80 kHz TABLE OF CONTENTS Description Page Description Page Table of Contents…………………..…………………..…...1 6.2.Power Board..……….........................................38 Revision List.…...................................................……......2 7.PCB Layout..……….............................................41 Important Safety Notice.….….............................……......3 7.1.Main Board………..…........................................41 1.Monitor Specification..............................………............4 7.2.Power Board….…..............................................42 2.LCD Monitor Description……….…………………….......5 7.3.Key Board………..…..........................................44 3.Operation Instruction.…………...................……...........6 3.1.General Instructions....................................…...........6 7.4.USB Board………..….........................................44 3.2.Control Buttons and Connections...............................6 8.Maintainability………............................................45 3.3.Adjusting the Picture…...................................8 8.1.Equipments and Tools Requirement…...............45 4.Input/Output Specification...............……………….......27 8.2.Trouble Shooting…..………...............................46 4.1.Input Signal Connector...............………..................27 9.Firmware and DDC Instruction……………….….54 4.2.Factory Preset Display Modes……..........................28 10.White-Balance,Luminance Adjustment…............69 4.3.Panel Specification…………..………………………..29 11.Mechanical Instructions …............ .............71 5.Block Diagram….........................................................32 5.1.Main Board…..….............................................32 12.Monitor Exploded View……................................75 5.2.Power Board…………..…………………………......33 13.BOM List…………..………………………............76 6.Schematic…………..….........................................34 6.1.Main Board..…….…...........................................34 SAFETY NOTICE ANY PERSON ATTEMPTING TO SERVICE THIS CHASSIS MUST FAMILIARIZE HIMSELF WITH THE CHASSIS AND BE AWARE OF THE NECESSARY SAFETY PRECAUTIONS TO BE USED WHEN SERVICING ELECTRONIC EQUIPMENT CONTAINING HIGH VOLTAGES. CAUTION: USE A SEPARATE ISOLATION TRANSFOMER FOR THIS UNIT WHEN SERVICING 1 21.5" LCD Color Monitor AOC e2236Vw Revision List Revision Date Revision History A00 Nov.-25-2011 Initial release Remark TIAASL2E6WA1BNE TIAASL2D6WA3BNE 2 21.5" LCD Color Monitor AOC e2236Vw Important Safety Notice Proper service and repair is important to the safe, reliable operation of all AOC Company Equipment. The service procedures recommended by AOC and described in this service manual are effective methods of performing service operations. Some of these service operations require the use of tools specially designed for the purpose. The special tools should be used when and as recommended. It is important to note that this manual contains various CAUTIONS and NOTICES which should be carefully read in order to minimize the risk of personal injury to service personnel. The possibility exists that improper service methods may damage the equipment. It is also important to understand that these CAUTIONS and NOTICES ARE NOT EXHAUSTIVE. AOC could not possibly know, evaluate and advise the service trade of all conceivable ways in which service might be done or of the possible hazardous consequences of each way. Consequently, AOC has not undertaken any such broad evaluation. Accordingly, a servicer who uses a service procedure or tool which is not recommended by AOC must first satisfy himself thoroughly that neither his safety nor the safe operation of the equipment will be jeopardized by the service method selected. Hereafter throughout this manual, AOC Company will be referred to as AOC. WARNING Use of substitute replacement parts, which do not have the same, specified safety characteristics may create shock, fire, or other hazards. Under no circumstances should the original design be modified or altered without written permission from AOC. AOC assumes no liability, express or implied, arising out of any unauthorized modification of design. Servicer assumes all liability. FOR PRODUCTS CONTAINING LASER: DANGER-Invisible laser radiation when open AVOID DIRECT EXPOSURE TO BEAM. CAUTION-Use of controls or adjustments or performance of procedures other than those specified herein may result in hazardous radiation exposure. CAUTION -The use of optical instruments with this product will increase eye hazard. TO ENSURE THE CONTINUED RELIABILITY OF THIS PRODUCT, USE ONLY ORIGINAL MANUFACTURER'S REPLACEMENT PARTS, WHICH ARE LISTED WITH THEIR PART NUMBERS IN THE PARTS LIST SECTION OF THIS SERVICE MANUAL. Take care during handling the LCD module with backlight unit -Must mount the module using mounting holes arranged in four corners. -Do not press on the panel, edge of the frame strongly or electric shock as this will result in damage to the screen. -Do not scratch or press on the panel with any sharp objects, such as pencil or pen as this may result in damage to the panel. -Protect the module from the ESD as it may damage the electronic circuit (C-MOS). -Make certain that treatment person’s body is grounded through wristband. -Do not leave the module in high temperature and in areas of high humidity for a long time. -Avoid contact with water as it may a short circuit within the module. -If the surface of panel becomes dirty, please wipe it off with a soft material. (Cleaning with a dirty or rough cloth may damage the panel.) 3 21.5" LCD Color Monitor 1. Monitor Specifications LCD Panel Resolution Model name Driving system Viewable Image Size Pixel pitch Video Separate Sync. Display Color Dot Clock Horizontal scan range Horizontal scan Size(Maximum) Vertical scan range Vertical scan Size(Maximum) Optimal preset resolution Highest preset resolution Plug & Play Input Connector Input Video Signal Power Source Power Consumption USB Downstream port (A type ) off timer Connector Type Signal Cable Type Physical Characteristics Dimensions & Weight: Temperature: Environmental Humidity: Altitude: AOC e2236Vw e2236Vw TFT Color LCD 547mm diagonal 0.248mm(H) x 0.248mm(V) R, G, B Analog lnterface & Digital Interface H/V TTL 16.7M Colors 148.5 MHz 30 kHz - 80 kHz 476.64mm 55 Hz - 75 Hz 268.11mm 1920 x 1080 (60 Hz) 1920 x 1080 (60 Hz) VESA DDC2B/CI D-Sub 15pin & DVI-D Analog: 0.7Vp-p(standard), 75 OHM, TMDS 100-240V~, 50/60Hz Typical < 42 W Standby < 1 W To USB device, loading < 100mA 0~24hours Select timing to turn off the monitor. 15-pin Mini D-Sub & DVI-D Detachable Height (with base) 396.6 mm Width 531.3mm Depth 206mm Weight (monitor only) 4.35 kg Weight (with packaging) 5.8 kg Operating 0° to 40° Non-Operating -20°to 60° Operating 10% to 85% (non-condensing) Non-Operating 5% to 80% (non-condensing) Operating 0~ 3000m (0~ 10000 ft ) Non-Operating 0~ 5000m (0~ 15000 ft ) 4 21.5" LCD Color Monitor 2. LCD Monitor Description AOC e2236Vw The LCD monitor will contain a main board, an adapter board, a converter board, two USB boards and a key board which house the flat panel control logic, brightness control logic and DDC. The power part will provide AC to DC Inverter voltage to drive the backlight of panel and the main board chips each voltage. Monitor Block Diagram Flat Panel and LED Drive LED backlight RS232 Connector Main Board Converter board For white balance adjustment in factory Key board mode USB board*2 Adapter board Video signal DDC HOST Computer AC-IN 100V-240V 5 21.5" LCD Color Monitor 3. Operating Instructions AOC e2236Vw 3.1 General Instructions Press the power button to turn the monitor on or off. The other control buttons are located at front panel of the monitor. By changing these settings, the picture can be adjusted to your personal preferences. - The power cord should be connected. - Connect the video cable from the monitor to the video card. - Press the power button to turn on the monitor, the power indicator will light up. 3.2 Control Buttons and Connections Power Press to turn on or turn off the monitor. Source (4 : 3 or wide) / Up Press key to change the screen aspect ratio between standard 4:3 format or Wide format. Source hot key : When the OSD is closed, press button will be Source hot key function (Only for the models with dual or more inputs) .Press Source button continuously to select the input source showed in the message bar , press Menu/Enter button to change to the source selected. Auto / Down Auto configure hot key: When the OSD is closed, press Auto button to do auto configure. 6 21.5" LCD Color Monitor AOC e2236Vw 1. Power 2. Analog (DB-15 VGA cable) 3.DVI To protect equipment, always turn off the PC and LCD monitor before connecting. 1. Connect the power cable to the AC port on the back of the monitor. 2. Connect one end of the 15-pin D-Sub cable to the back of the monitor and connect the other end to the computer's D-Sub port. 3. (Optional – Requires a video card with DVI port) - Connect one end of the DVI cable to the back of the monitor and connect the other end to the computer’s DVI port. 4. Turn on your monitor and computer. If your monitor displays an image, installation is complete. If it does not display an image, please refer Troubleshooting. 7 21.5" LCD Color Monitor AOC e2236Vw 3.3 Adjusting the Picture Eco mode ---DCR, Standard, Text, Internet, Game, Movie, Sports DCR 8 21.5" LCD Color Monitor AOC e2236Vw Standard Text Internet 9 21.5" LCD Color Monitor AOC e2236Vw Game Movie Sports Notes : When Eco mode is not set as “Standard”, Contrast and Brightness can not be adjusted; When DCR is set as “On”, Contrast, Brightness, Eco mode and Gamma can not be adjusted. 10 21.5" LCD Color Monitor AOC e2236Vw Color Boost --- Full Enhance, Nature Skin, Sky-Blue, Green Field, Auto Detect, Demo, Off, Exit Full Enhance Nature Skin Sky-Blue 11 21.5" LCD Color Monitor AOC e2236Vw Green Field Auto Detect Demo 12 21.5" LCD Color Monitor AOC e2236Vw Off Exit Notes : Full Enhance: Total color saturation is enhanced, suitable for vivid pictures. Natural Skin: Suitable for human portrait. Green Field: Suitable for large area of green. Sky Blue: Suitable for sky or ocean scene. Auto Detect: Suitable for outdoor or garden. Demo: Screen divided into two for comparison purpose. 13 21.5" LCD Color Monitor AOC e2236Vw Luminance ---Brightness,Contrast, Gamma Brightness Contrast Gamma 14 21.5" LCD Color Monitor AOC e2236Vw Exit Notes : When Eco mode is not set as “Standard”, Contrast and Brightness can not be adjusted; When DCR is set as “On”, Contrast, Brightness, Eco mode and Gamma can not be adjusted. Image Setup --- Clock, Phase, H.Position, V.Position, Exit Clock Phase H.Position 15 21.5" LCD Color Monitor AOC e2236Vw V.Position Exit Notes : When the input source is digital signal like DVI or HDMI, Image Setup can not be adjusted. 16 21.5" LCD Color Monitor AOC e2236Vw Color Temperature ---User-R , User-G , User-B, Normal, Warm, Cool, sRGB, Exit User-R User-G User-B 17 21.5" LCD Color Monitor AOC e2236Vw Normal Warm Cool 18 21.5" LCD Color Monitor AOC e2236Vw sRGB Exit Notes : One of DCR, Color Boost, and Picture Boost functions is active, the other two function is turned off accordingly. 19 21.5" LCD Color Monitor AOC e2236Vw Picture Boost --- V.Position, H.Position, Contrast, Brightness, Frame Size, Bright Frame, Exit V.Position H.Position Contrast 20 21.5" LCD Color Monitor AOC e2236Vw Brightness Frame Size Bright Frame 21 21.5" LCD Color Monitor AOC e2236Vw Exit Notes : One of DCR, Color Boost, and Picture Boost functions is active, the other two function is turned off accordingly. Extra ---Language, Reset, DDC-CI,OSD Timeout, Transparency, V. Position, H. Position, Off Timer, Exit Language 22 21.5" LCD Color Monitor AOC e2236Vw Reset DDC-CI OSD Timeout Transparency 23 21.5" LCD Color Monitor AOC e2236Vw V. Position H. Position 24 21.5" LCD Color Monitor AOC e2236Vw Off Timer Exit 25 21.5" LCD Color Monitor AOC e2236Vw Exit LED Indicator 26 21.5" LCD Color Monitor 4. Input/Output Specification AOC e2236Vw 4.1 Input Signal Connector D-SUB connector PIN NO. DESCRIPTION PI N NO. DESCRIPTION 1 Video-Red 9 +5V 2 Video-Green 10 Ground 3 Video-Blue 11 N.C. 4 N.C. 12 DDC-Serial data 5 Detect Cable 13 H-sync 6 GND-R 14 V-sync 7 GND-G 15 DDC-Serial clock 8 GND-B 27 21.5" LCD Color Monitor AOC e2236Vw 4.2 Factory Preset Display Modes STAND VGA VGA VGA VGA Dos-mode SVGA SVGA SVGA SVGA SVGA XGA XGA XGA XGA *** SXGA SXGA WXGA+ WSXGA HD HORIZONTAL VERTICAL FREQUENCY(kHZ) FREQUENCY(Hz) 31.469 35 37.861 37.5 31.469 35.156 37.879 48.077 46.875 49.725 48.363 56.476 60.023 60.241 60 63.981 79.976 55.935 65.29 67.5 59.94 66.667 72.809 75 70.087 56.25 60.317 72.188 75 74.55 60.004 70.069 75.029 74.927 60 60.02 75.025 59.887 59.954 60 RESOLUTION 640×480 @60Hz 640×480 @67Hz 640×480 @72Hz 640×480 @75Hz 720×400 @70Hz 800×600 @56Hz 800×600 @60Hz 800×600 @72Hz 800×600 @75Hz 832×624 @75Hz 1024×768 @60Hz 1024×768 @70Hz 1024×768 @75Hz 1024×768 @75Hz 1280×960 @60Hz 1280×1024 @60Hz 1280×1024 @75Hz 1440×900 @60Hz 1680X1050 @60Hz 1920×1080@60Hz 28 21.5" LCD Color Monitor AOC e2236Vw 4.3 Panel Specification 4.3.1 Display Characteristics AUO M215HW01 29 21.5" LCD Color Monitor AOC e2236Vw 4.3.2 Optical Characteristics AUO M215HW01 Ta=25℃ 4.3.3 Electrical Characteristics 1.TFT LCD Module: AUO M215HW01 Note1:Measurement conditions: The duration of rising time of power input is 470us. 30 21.5" LCD Color Monitor AOC e2236Vw 2.Back Light Unit: AUO M215HW01 Ta=25℃ 31 21.5" LCD Color Monitor 5. Block Diagram AOC e2236Vw 5.1 Main Board 715G3329 1 2 FLASH MEMORY MX25L2026MI Crystal 14.31818MHz LCD Interface (X401) (CN301) Scalar TSUMU58PWHL-LF-1 (Include :MCU,ADC,OSD etc) (U402) (U401) D-Sub DVI Connector Connector (CN101) (CN102) 32 Key Control Interface (CN402) 21.5" LCD Color Monitor AOC e2236Vw 5.2 Power Board Adapter 715G3189P02LED001S AC input Bridge Rectifier and Filter EMI filter Transformer 14.5V Rectifier diodes 5V Start Resistor (R920,R921,R922) PWM Control Power Switch (Q901) Feedback Circuit Photo coupler Converter 715G4137P01000004S 12V L801 ZD801 LED MOSFET (Q801) DIM ENA (CN805) PWM Control TA9690GN (IC801) 33 21.5" LCD Color Monitor 6. Schematic AOC e2236Vw 6.1 Main Board 715G3329 1 2 FB102 VGA_B+ 0R05 1/10W 5% R103 1K 1/16W 5% R104 1K 1/16W 5% R106 2K2 1/16W 5% R107 C103 C104 2K2 1/16W 5% 22pF 22pF DSUB_H DSUB_V DSUB_SCL DSUB_SDA 1 2 3 DDC1_SCL DSUB_SCL 15 14 100R 1/16W 5% 13 DDC1_SDA DSUB_SDA 12 11 FB103 V_Sy nc VGA_G+ 1 2 R111 BEAD VGA_PLUG DSUB_5V VGA_G+ VGA_R+ U103 AZC199-04S 1 2 3 I/O1 I/O4 GNDVDD I/O2 I/O3 6 5 4 100R 1/16W 5% C109 5pF/50V R112 75R 1/16W 5% 候綼 U103 C124 0.1uF/16V 17 100R 1/16W 5% 100R 1/16W 5% R114 VGA_G- VGA_PLUG FB101 VGA_B+ VGA_R+ 1 BEAD 100R 1/16W 5% R115 2 R116 C113 5pF/50V 75R 1/16W 5% 候綼 U101 VGA_R- C106 0.047uF DSUB_B- 5 C107 1000pF DSUB_SOG 5 C108 0.047uF DSUB_G+ 5 C110 0.047uF DSUB_G- 5 C111 0.047uF DSUB_R+ 5 DSUB_R- 5 C114 0.047uF R117 DVI_5V CMVCC1 100R 1/16W 5% GND GND DAT0+ DAT0DAT1+ DAT1DAT2+ DAT2DAT3+ DAT3DAT4+ DAT4DAT5+ DAT5clk+ clk- DVI 1_5V DDC2_SCL DDC2_SDA R118 100R 1/16W 5% R119 100R 1/16W 5% DDC2_SCL DDC2_SDA R120 10K 1/16W 5% D104 BAV70 5 5 ESD_VCC R140 3 DVI_HPD NC 11 3 19 22 C115 R122 NC 0.1uF/16V 18 17 10 9 2 1 13 12 5 4 21 20 23 24 R126 R127 R128 R129 R130 R131 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 5%RX0P 5%RX0N 5%RX1P 5%RX1N 5%RX2P 5%RX2N RX0P RX0N RX1P RX1N RX2P RX2N HDCP_CTRL 5 NC Q101 NC R124 4K7 1/16W 5% R125 4K7 1/16W 5% R123 4K7 1/16W 5% 8 7 6 5 DDC1_SCL DDC1_SDA 5 5 5 5 5 5 5 C116 U101 0.22uF16V 1 A0 2 A1 3 A2 4 GND VCC WP SCL SDA DDC_WP AT24C02BN-SH-T CMVCC1 DVI 1_5V FB104 DVI_5V FB105 10R 1/16W 5%RXCP 10R 1/16W 5%RXCN R132 R134 1 2 3 U107 AZC199-04S I/O1 I/O4 GNDVDD I/O2 I/O3 ESD_VCC1 6 5 4 1 2 3 U105 AZC199-04S I/O1 I/O4 GNDVDD I/O2 I/O3 ESD_VCC1 6 5 4 1 2 3 U106 AZC199-04S I/O1 I/O4 GNDVDD I/O2 I/O3 C122 300 OHM VCC3.3 DVI_HPD C119 NC NC ESD_VCC1 C117 R137 10K 1/16W 5% 6K8 1/16W 5% VGA_PLUGR139 4K7 1/16W 5% DET_CABLE R136 4K7 1/16W 5% R138 4K7 1/16W 5% DDC2_SCL DDC2_SDA 5 候綼 U106 5 DDC_WP TPV ( Top 絬隔瓜絪腹 Key Component 300 OHM Date 34 Victory Electronics Co . , G3329-C-2-X-2-090401 2.0.INPUT Wednesday , June 10, 2009 Ltd. ) 8 7 6 5 VCC WP SCL SDA 0.22uF16V U102 1 A0 2 A1 3 A2 4 GND AT24C02BN-SH-T ESD_VCC2 FB110 1000pF D108 BAV70 R133 10K 1/16W 5% C118 候綼 U105 300 OHM C121 1000pF 5 5 R135 NC ESD_VCC1 RXCP RXCN ESD_VCC1 6 5 4 C120 候綼 U107 GND POWER DGND 10R 10R 10R 10R 10R 10R R121 2 1/3shield 2/4shield 0/5shield clk shield 8 15 6 7 14 16 3 VSY NC SY NC GND DDC SCL DDC SDA +5V HPD DSUB_5V CMVCC1 2 3,4 CN102 JACK 5 ESD_VCC C101 NC 26 25 5 DDC1_SDA R113 470R 1/16W 5% R110 C112 NC VGA_BVGA_B+ ZD104 VGA_G- RLZ5.6B VGA_G+ VGA_RVGA_R+ 100R 1/16W 5% R109 ESD_VCC H_Sy nc 6 5 4 DSUB_B+ 1 DDC1_SCL I/O1 I/O4 GNDVDD I/O2 I/O3 C102 0.047uF C105 5pF/50V 75R 1/16W 5% U104 AZC199-04S 16 5 10 5 9 4 8 3 7 2 6 1 R108 5 5 VGA_B- CN101 R101 100R 1/16W 5% R105 2 BEAD 1 H_Sy nc R102 V_Sy nc 1 OEM MODEL NEW R SERIES Size TPV MODEL Rev AOC 2236VWA PCB NAME Sheet 2 of 5 称爹 B B <称爹> 21.5" LCD Color Monitor AOC e2236Vw CN301 5 PA[0..9] PA[0..9] 5 PA0 PA1 PA2 PA3 PA4 PA5 PA6 PA7 PA8 PA9 PB[0..9] PB[0..9] PB0 PB1 PB2 PB3 PB4 PB5 PB6 PB7 PB8 PB9 LVA3P LVA3M LVACKP LVACKM LVA2P LVA2M LVA1P LVA1M LVA0P LVA0M LVB3P LVB3M LVBCKP LVBCKM LVB2P LVB2M LVB1P LVB1M LVB0P LVB0M CN302 LVB0M LVB1M LVB2M LVBCKM LVB3M LVA0M LVA1M LVA2M LVACKM LVA3M RXO0RXO1RXO2RXOCRXO3RXE0RXE1RXE2RXECRXE3- 29 27 25 23 21 19 17 15 13 11 9 7 5 3 1 30 28 26 24 22 20 18 16 14 12 10 8 6 4 2 RXO0+ RXO1+ RXO2+ RXOC+ RXO3+ RXE0+ RXE1+ RXE2+ RXEC+ RXE3+ CONN LVB0P LVB1P LVB2P LVBCKP LVB3P LVA0P LVA1P LVA2P LVACKP LVA3P PANEL_VCC LVB0M LVB0P LVB1M LVB1P LVB2M LVB2P RXO0RXO0+ RXO1RXO1+ RXO2RXO2+ LVBCKM LVBCKP LVB3M LVB3P LVA0M LVA0P RXOCRXOC+ RXO3RXO3+ RXE0RXE0+ LVA1M LVA1P RXE1RXE1+ LVA2M LVA2P LVACKM LVACKP LVA3M LVA3P RXE2RXE2+ RXECRXEC+ RXE3RXE3+ PANEL_VCC PANEL_VCC FB301 1 R302 C301 220 OHM 1/4W 220 OHM 1/4W 0.1uF/16V NC 2 120 OHM + C305 100UF25V CMVCC1 2,4 R301 30 29 28 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 080912 CMVCC1 10K 1/16W 5% R306 Q301 D D D D 5 6 7 8 R305 R304 5 Q302 PPWR_ON# R307 2N3904S-RTK/PS R303 22K 1/16W 5% 4K7 1/16W 5% C302 NC/AO4411 CMVCC1 4 3 2 1 56K 1/16W 5% U301 G S S S AO3401 0.22uF16V NC C304 0.1uF/16V C303 3D 1uF/25V 1 G R308 10K 1/16W 5% 2 S AO3401L OEM MODEL NEW R SERIES Size 絬隔瓜絪腹 G3329-C-2-X-2-090401 TPV MODEL Rev Key Component 3.0.OUTPUT PCB NAME T P V ( Top Date 35 Victory Electronics Co . , Wednesday , June 10, 2009 Ltd. ) Sheet AOC 2236VWA 3 of 5 称爹 B B <称爹> 21.5" LCD Color Monitor CMVCC1 AOC e2236Vw 2,3 SOT 252 9 8 7 6 5 4 3 2 1 CMVCC1 CMVCC1 BKLT-VBRI BKLT-EN PANEL_ID# Volume# Mute1 VIN VOUT ADJ(GND) 3 2 1 Both 223 and 252 foot-print CN701 R709 NC R710 NC Volume# PANEL_ID# 5 Mute 5 CMVCC1 0.1uF/16V VIN VOUT C708 U701 AP1117E33LA 2,3,5 CMVCC1 C707 C709 0.1uF/16V + 0.1uF/16V 100UF25V VCC3.3 R702 R703 10K 1/16W 5% BKLT-EN 3 10K 1/16W 5% U704 NC/AP1117E18LA 2 VI VO 1 on_BACKLIGHT 5 4 R704 Q701 22K 1/16W 5% 2N3904S-RTK/PS SOT 223 4 0.1uF/16V GND C702 R708 3.3OHM 2W U703 R701 NC 3 IN OUT 2 GND VCC3.3 C713 R705 VCC1.8 AZ1117D-1.8-E1 C705 0.1uF/16V + C704 0.1uF/16V 1 DGND 2 VSS lock type C712 0.1uF/16V 1 C701 VCC3.3 SOT 223 5 3 CONN U702 NC/AP1117D33L-13 100UF25V 1K 1/16W 5% BKLT-VBRI R706 adj_BACKLIGHT 5 100R 1/16W 5% OEM MODEL NEW R SERIES Size 絬隔瓜絪腹 TPV G3329-C-2-X-2-090401 TPV MODEL Rev Key Component 4.0.POWER PCB NAME Date 36 ( Top Victory Electronics Co . , Wednesday , June 10, 2009 Ltd. ) Sheet AOC 2236VWA 4 of 5 称爹 B B <称爹> 21.5" LCD Color Monitor AOC e2236Vw VCC3.3 FB402 VPLL VCC3.3 FB401 300OHM AVDD 300OHM C408 0.1uF/16V 3 4 6 7 9 10 12 13 100 1 0.1uF/16V 26 C417 VCC3.3 25 1 2 3 4 WP 8 7 6 5 CS# VCC DO HOLD# WP# CLK VSS DI 3 EN25F20-100GCP 37 38 39 40 48 PPWR_ON# C419 84 + CMVCC1 REFP C420 47pF R423 0R05 1/16W 96 2 100K 1/16W 5% 1 97 LVB3P LVB3M LVBCKP LVBCKM LVB2P LVB2M LVB1P LVB1M LVB0P LVB0M GPIO_P23 GPIO_P43 GPIO_P42 GPIO_P47 GPIO_P46 GPIO_P22/PWM0 PWM2/GPIO_P24 LVDS SDO SCZ SCK SDI GPIO_P25 PWM3/GPIO_P27 GPIO_P00/SAR0 GPIO_P01/SAR1 GPIO_P02/SAR2 GPIO_P03/SAR3 GPIO_P45/PWM1 RST GPIO_P07 GPIO_P15 PWM1/GPIO_P16 GPIO_P12 GPIO_P13 GPIO_P14/PWM0 XOUT X401 14.31818MHz C421 47pF 34 PA0 PA1 PA2 PA3 PA4 PA5 PA6 PA7 PA8 PA9 CMVCC1 R402 R451 1K 1/16W 5% 1 PB[0..9] PB0 PB1 PB2 PB3 PB4 PB5 PB6 PB7 PB8 PB9 67 68 69 70 71 72 73 74 77 78 36 45 46 R425 3 PB[0..9] 3 VMPLL VCC3.3 300OHM C413 0.1uF/16V 0R05 1/16W C414 0.1uF/16V LF_B 0R05 1/10W 5% VCC3.3 C403 C404 C402 4.7uF/10V 0.1uF/16V C406 C405 0.1uF/16V 0.1uF/16V R446 POWER_KEY # NC DDC_WP 0.1uF/16V 2 R406 VCC1.8 Q401 PANEL_ID# WP 22K 1/16W 5% on_BACKLIGHT 4 adj_BACKLIGHT 4 R415 R416 R417 100R 1/16W 5% 100R 1/16W 5% 100R 1/16W 5% R419 R420 0R05 1/16W NC R424 100R 1/16W 5% BUZZER NC KEY 1 KEY 2 R407 C416 10K 1/16W 5% 0.1uF 16V VDDC VCC1.8 DET_CABLE C410 C411 R434 Volume# Mute 0.1uF/16V NC 2 R422 2 C412 C409 0.1uF/16V 0.1uF/16V 0.1uF/16V R427 LED G_B LED O HDCP_CTRL 4 LMBT3904LT1G 4 CMVCC1 85 86 R426 VDDP VCC3.3 2,4 For detect function, depend on FW EE_WP 91 92 93 94 95 99 C415 0.1uF/16V Q405 2N3906S-RTK/PS NC R445 NC R409 100R 1/16W 5% 87 88 89 90 FB410 VDVI 300OHM DVI 1_5V R447 NC 41 42 35 47 PA[0..9] VCC3.3 FB404 NC VCC3.3 R452 1K 1/16W 5% R404 2 51 66 82 REFM 10UF50V R421 VDDC VDDC VDDC VDDC 24 32 49 56 75 VDDP VDDP VDDP VDDP 16 98 TSUMU58EHL-LF-1 U402 R412 10K 1/16W 5% 81 54 55 58 59 60 61 62 63 64 65 PA[0..9] C401 0.22uF16V VCTRL LVA3P LVA3M LVACKP LVACKM LVA2P LVA2M LVA1P LVA1M LVA0P LVA0M R405 RX2P RX2N RX1P RX1N RX0P RX0N RXCKP RXCKN DDCD_SDA DDCD_SCL 15 R401 390 OHM 1/16W REXT AVDD C407 0.1uF/16V VDDC 3 RX2P RX2N RX1P RX1N RX0P RX0N RXCP RXCN DDC2_SDA DDC2_SCL RIN0P RIN0M GIN0P GIN0M SOGIN0 BIN0P BIN0M HSY NC0 VSY NC0 DDCA_SDA/RS232_TX DDCA_SCL/rs232_RX AVDD_33 2 2 2 2 2 2 2 2 2 2 23 22 20 19 21 18 17 27 28 30 31 VPLL AVDD VDDP AVDD_33 DSUB_R+ DSUB_RDSUB_G+ DSUB_GDSUB_SOG DSUB_B+ DSUB_BDSUB_H DSUB_V DDC1_SDA DDC1_SCL AVDD_33 2 2 2 2 2 2 2 2 2 2 2 AVDD_33 AVDD_33 8 14 VDVI VMPLL 100R 1/16W 5% 4 4 0R05 1/16W C438 NC XIN R428 100R 1/16W 5% C422 0.1uF/16V80 CMVCC1 BYPASS R430 MSCL MSDA R453 NC NC 2 CMVCC1 R455 NC R457 NC VCC3.3 R454 CMVCC1 R459 NC VCC3.3 NC R458 NC 2 5 11 29 33 50 57 76 79 83 MODE[0] MODE[1] R429 NC 44 43 GND GND GND GND GND GND GND GND GND GND GPIO_P10/I2C_MCL GPIO_P11/I2C_MDA 52 53 LED G_B LED O Q407 NC Q408 NC LED_GRN/BLUE VCC3.3 Eon SST For user data, WB, EDID, HDCP are saved in Flash. U402 010A Befor AOC ID2007 OSD 020A For ID2008 ID2009 Eon U402 020 For All model Cs and Cd (C420, C421) 蔼 (93G 22-53B-H) 18 pF 27 pF 瑉红 (93G 22-53-J) 32 pF 56 pF U402 SST CL of SPEC For NVRAM U403 C423 M24C04-WMN6TP 0.22uF16V Without NVRAM Max condition for LED: 1. Vcc = 3.3 V 2. Current = 12 mA FW need to be modified. Indirect LED Direct LED NC R419 10K 1/16W 5% 100R 1/16W 5% NC R420 10K 1/16W 5% 100R 1/16W 5% R453 0R 1/16W 5% 2.2K 1/16W 5% R429 100R 1/16W 5% NC R430 100R 1/16W 5% NC R455 R440 10K 1/16W 5% NC R461 R441 10K 1/16W 5% NC R457 0R 1/16W 5% R442 10K 1/16W 5% NC R459 2.2K 1/16W 5% R462 NC NC VCC3.3 CN404 CN401 NC NC 2N3906S NC NC NC R431 R432 R414 0R05 1/16W R433 KEY 1 KEY 2 POWER_KEY # LED_GRN/BLUE LED_ORANGE NC/CONN C431 C432 C433 ZD401 NC C434 C435 CN402 0R 1/16W 5% Q408 R411 R418 0R05 1/16W NC/CONN NC NC 1 2 3 4 5 6 6 5 4 3 2 1 0R 1/16W 5% 2N3906S 1 3 5 7 NC/CONN NC Q407 R408 CN403 2 4 6 8 3.9K OHM +-1% 1/16W X401 NC NC NC 3.9K OHM +-1% 1/16W 1 2 3 4 NC VCC NC WC E1 SCL E2 SDA VSS NC U403 NC C423 8 7 6 5 R460 NC 0.1uF/16V EE_WP R436 R442 NC R462 NC NC 10K 1/16W 5% NC R441 NC LED_ORANGE R456 22R 1/16W 5% R435 R440 NC MSCL MSDA X'TAL Normal Function : CL = Cs + ((Cg*Cd)/(Cg+Cd)) P.S : Assume Cs = 4 pF R461 0R05 1/10W 5% 7 6 5 4 3 2 1 CONN VCC3.3 CN405 NC/CONN 1 2 3 4 5 6 7 FB405 NC TOUCH_POWER CN406 CMVCC1 LF_B For BUZZER control board or Touch Panel 1 2 3 BUZZER C436 NC/CONN 1uF 10V OEM MODEL NEW R SERIES Size 絬隔瓜絪腹 G3329-C-2-X-2-090401 TPV MODEL Rev Key Component 5.0.SCALER PCB NAME TPV Date 37 ( Top Victory Electronics Co . , Wednesday , June 10, 2009 Ltd. ) Sheet AOC 2236VWA 5 of 5 称爹 Custom B <称爹> 21.5" LCD Color Monitor AOC e2236Vw 6.2 Power Board Adapter 715G3189P02LED001S R904 30 OHM 1/4W L903 C910 2N2 500V C919 2N2 500V ZD901 R906 30 OHM 1/4W + 1 1 ! C907A 100uF 450V 3 + 2 + + C907 NC/47uF M 450V C906 R919 1500PF2KV 100K OMH 2W +-5% 2 3 4 - D902 4 ! 4 Relayout 3.3 OHM 1/4W R908 30 OHM 1/4W 10 1 C911 C920 2N2 500V 2N2 500V F902 FUSE +5V R917 1K 1/10W 1% L902 R909 30 OHM 1/4W 2.2 OHM 1/4W C913 680uF 10V + + C914 F601 0R05 4A 1/4W 470UF M 16V D904 31DQ06FC3 R921 3.3 OHM 1/4W D906 31DQ06FC3 R901 620K +-1% 1/4W D90 1 FR10 3 93 G 6 03 8T 52 T R922 3.3 OHM 1/4W Relayout R902 620K +-1% 1/4W ! MTZJ T-72 16B R925 + 82K +-1% 1/8W C901 82pF D V 7 NR901 NTCR R910 100 OHM 1/4W C918 10uF/50V R911 NC IC902 PC123X2Y FZOF F 3 R914 NC R912 10K 1/10W 5% R924 6R8 +-5% 1/8W 4 S 5 C903 330pF/250V C X IC901 TOP255EN 2 Change 5A 5 OHM 17.4V 2 1 C904 0.47UF C902 330pF/250V ZD902 R923 1 10K 1/8W 1% 3 R900 620K +-1% 1/4W 5 C916 10N 16V R907 30 OHM 1/4W 7 6 ! L901 30mH ! R926 R916 470 OHM 1/10W Q901 KTD1028 D905 31DQ10FC 1 2 FR107 MTZJ T-72 18B 2 3 R920 R918 250OHM2W C912 680uF 25V D903 31DQ10FC 9 8 8. 4 BD901 KBP208G +14.5V 1 ! T901 POWER X'FMR R927 0R05 4A 1/4W 2 R905 30 OHM 1/4W C900 1000PF/250VAC R913 10K 1/10W 1% C905 100nF 50V R903 11K 1/8W 1% 11.3K 4/13 + F901 C908 47uF/50V C915 100N 50V IC903 KIA431A-AT/P R915 9.31KOHM +-1% 1/10W ! 2 3 2 CN901 1 HS1 HEAT SINK(IC901) SOCKET 1 2 CN902 FB902 BEAD 1 2 DIM_INPUT ON/OFF_INPUT VOL MUTE +5V GND1 GND 1 2 GND2 GND 1 2 C917 100N 50V GND3 GND 1 2 3 4 5 6 7 8 9 10 +14.5V 1 2 3 4 5 6 7 8 9 DIM_OUTPUT ON/OFF_OUTPUT CONN CN903 Wire Harness 1 2 T P V ( Top Electronics Co . , Ltd. ) TPV MODEL Key Component 02.POWER PCB NAME Wednesday , September 23, 2009 e936vw OEM MODEL G3189-POC-LED-X-6-090825 Date 38 Victory 絬 隔 瓜絪 腹 Sheet ADPC91503HC3 715G3189-POC-LED 2 of 3 Size Rev 称爹 Custom C ODM MODEL +5V1 21.5" LCD Color Monitor AOC e2236Vw NC +5V1 ON/OFF_INPUT R621 R622 NC Q621 NC R620 NC BKLT-VBRI PANEL ON/OFF_OUTPUT R624 NC R623 0R05 1/10W NC +5V1 DIM_INPUT R626 R627 NC Q622 NC R625 NC BKLT-EN PANEL DIM_OUTPUT R629 NC R628 0R05 1/10W T P V ( Top Victory Electronics Co . , Ltd. ) OEM MODEL e936vw Size 絬隔瓜絪腹 G3189-POC-LED-X-6-090825 TPV MODEL ADPC91503HC3 Key Component 04.BUFEER PCB NAME 715G3189-POC-LED Date Wednesday , September 23, 2009 Sheet 39 3 of 3 Rev 称爹 A C ODM MODEL 21.5" LCD Color Monitor AOC e2236Vw Converter 715G4137P01000004S R852 NC R853 NC ZD801 1 1 2 3 4 C802 100uF 50V DIM ENA SK310B Q801 + C801 0.1uF 50V S2 G2 S1 G1 2 D2 D2 D1 D1 8 7 6 5 C804 33U + R833 R832 R831 R830 C810 0.1uF 50V C803 0.1uF 50V R844 10 OHM 1/10W R845 NC 0.3 OHM +-1% 1/4W R846 R847 R801 NC 0.3 OHM +-1% 1/4W C816 1nF 50V R806 10K 1/10W 5% R804 30K +-1% 1/10W R842 51K +-1% 1/10W OHM 1/10W OHM 1/10W OHM 1/10W OHM 1/10W CN802 NC 10 9 8 7 6 5 4 3 2 1 R829 1 OHM 1/10W APM8005K R825 0R05 1/4W 1 1 1 1 OVP1 R805 150KOHM 1/10W 1 2 3 4 5 6 7 8 9 10 11 12 PWM STATUS ISEN1 NC ISEN2 SSTCMP ISEN3 COMP ISEN4 SEL GNDA VIN ISEN8 GNDP ISEN6 VREF ISEN7 LDR OVP ISEN5 ISET ISW RT ENA 24 23 22 21 20 19 18 17 16 15 14 13 R828 1 OHM 1/10W R827 1 OHM 1/10W R826 1 OHM 1/10W R813 10K 1/10W 5% R812 C806 2U2 25V IC801 TA9690 A1 R807 C805 0.47uF 16V 100 OHM 1/10W R810 R849 R857 R855 R848 0R05 1/10W 1K 1/10W 5% CN805 R808 NC CONN 6 5 4 3 2 1 C807 2.2U25V 10 OHM 1/10W R809 100K 1/10W 5% R814 10 OHM 1/10W Vout OVP2 OVP1 R822 1M 1/8W 5% C811 change short item. CN804 cancel ,add CN801 20100207 R823 MAX0R01 R824 36KOHM +-1% 1/10W 32MA 27.5MA Iout 20mA 25mA R804 56K 27K 30K 30K R842 56K 150K 51K 75K OEM MODEL HP X23LED SEC Size R815 56K 27K 絬隔瓜絪腹 G4137-P01-000-0040-2-100510 TPV MODEL Rev 1.0 R843 56K 150K Key Component 02.CONVERTER PCB NAME 称爹 <称爹> TPV Date ( Top Victory Electronics Co . , Wednesday , June 30, 2010 40 Ltd. ) Sheet LNPCAD561SHA1 715G4137-P01-000-0040 2 of 2 12 L801 33u 11 CN801 CONN +12V 7 11 10 9 8 7 6 5 4 3 2 1 8 12 Vout A3 21.5" LCD Color Monitor 7. PCB Layout AOC e2236Vw 7.1 Main Board 715G3329 1 2 41 21.5" LCD Color Monitor AOC e2236Vw 7.2 Power Board Adapter 715G3189P02LED001S 42 21.5" LCD Color Monitor AOC e2236Vw Converter 715G4137P01000004S 43 21.5" LCD Color Monitor AOC e2236Vw 7.3 Key Board 715G3371 2 7.4 USB Board 715G3501 3 715G2663 2 44 21.5" LCD Color Monitor 8. Maintainability AOC e2236Vw 8.1 Equipments and Tools Requirement 1. Voltmeter. 2. Oscilloscope. 3. Pattern Generator. 4. DDC Tool with an IBM Compatible Computer. 5. Alignment Tool. 6. LCD Color Analyzer. 7. Service Manual. 8. User Manual. 45 21.5" LCD Color Monitor AOC e2236Vw 8.2 Trouble Shooting 1. No Power No power NG Check power cable is tightened? Re-plug the power cable OK NG Check Power “On/Off” is “On”? Turn on the Power “On/Off” switch OK NG Check the LED indicate is OK? Check the AC power OK Replace the converter board NG Replace main board and check connections NG Replace key board and check connections 46 21.5" LCD Color Monitor AOC e2236Vw 2. No Video (Power LED Blue) No Video (Power LED Blue) Press the power button is OK? NG Replace the main board OK Replace the converter board OK The end NG Replace the main board and connection OK The end NG Check the LVDS/FFC cable or panel NG Replace the key board 47 OK Replace the LVDS/FFC cable or panel 21.5" LCD Color Monitor 3. AOC e2236Vw DIM DIM (image overlap, focus or flicker) OK Reset in factory mode The end NG OK Set to the optimal frequency, select the recommended frequency The end NG OK Readjust the phase and pixel clock in the user mode The end NG OK Pull out signal cable and check “Self Test Feature Check” is ok? Check the signal cable and the PC NG NG OK Replace the main board The end NG Replace the panel OK 48 21.5" LCD Color Monitor AOC e2236Vw 4. Color is not optimal Color is not optimal Color shift Miss color Reset the factory mode Replace the signal cable NG OK NG In the user mode, set the” color settings” until customer satisfy The end Pull out the signal cable and check the screen color display is normal? NG OK NG Replace the signal cable or PC Replace the main board 49 21.5" LCD Color Monitor 9.Firmware and DDC Instruction AOC e2236Vw 9.1 Firmware Instruction(TSUM IC ISP for exemple TSUMO58GDJ) 1. OPERATION CONDITIONS: 1) An i486 (or above) personal computer or compatible. 2) Microsoft operation system Windows XP. 3) “MSTAR ISP Tool V4.5.0.7.7”programs. 4) Printer cable and VGA cable. 5) ISP board (PN: 715GT039-A). 2. Connection: 1) LPT cable connect PC and ISP board ; 2)VGA cable connect monitor and ISP board ; 3)Reference picture as below ISP Board (TPV P/N:715GT039-A) 3.Software list: 1)LPT driver: 2)MSTAR ISP TOOL: Eg: TSUMO58GDJ_LGLM215WF4_20100518_V005_8143.BIN 3)Setup LPT driver:run Port95nt icon: 4)USB driver install 50 21.5" LCD Color Monitor AOC e2236Vw 4 .Program: 1)Run MSTAR ISP Tool V4.5.0.7.7,interface as below: 2) Choose CONFIG icon ,interface as below : Setting as : Port type :LPT1 Speed :50KHZ 51 21.5" LCD Color Monitor AOC e2236Vw 3)Choose DEVICE,and choice WP Pin pull to high during ISP : 4)Choose CONNECT icon ,and interface show Device type , PC and monitor communications successful, click “OK”. 52 21.5" LCD Color Monitor AOC e2236Vw 5)Click “Read”, show as follow picture, then choose correct software to click “open. PS:For exemple TSUMO58GDJ_LGLM215WF4_20100518_V005_8143.BIN 6 )Then ,as below : 7. 53 21.5" LCD Color Monitor AOC e2236Vw 7) Click icon“Restore”as following 8) Show the interface as follows after press the AUTO button 54 21.5" LCD Color Monitor AOC e2236Vw 9).Then , press Run icon ,as below,Show Blank OK, Program OK, Verify OK, It’s successfully if interface show PASS. 10) AC off, wait about one minute, after the elextricity large capacitance of power board release, then AC on, otherwise, the key button and power button cann't work. 5.Check Software Version and auto color and reset: You should check the program code is right in factory mode ;(about the method of enter factory mode ,pls reference the service manual ) 5.1Auto level : 1)Monitor display gray pattern ; 2)Enter the factory mode ; 55 21.5" LCD Color Monitor AOC e2236Vw 3)Choise the AUTO LEVEL icon and run it. 4)Check the gray pattern is clear ; 5)Change to full black pattern , and check the display there is no noise . 5.2Reset Monitor would change to default setting after reset . 5.3power off Monitor must be turned off after rework code. 6:HDCP Write SOP I. Prepare condition: 1. Prepare one PC and the system is WIN98/NT/2000/XP, make sure the PC have Print Port. 2. Install Port95nt Software, the way of the install Port95 (LPT PORT drive): a. selects the software of Port95nt.exe, and run it, b. After install ok, restart the PC. 3. Connect the cable and Jig: a. Use the Print cable to connect the PC and HDCP card. b. Connect the VGA cable with the ISP record card, the picture of Print cable, VGA cable and ISP card as below: Connect to PC LPT DC 12V Connect to Monitor Connect to Signal Source (e.g.: Chroma/PC etc) ISP Tool TPV P/N: 715GT034-B 56 21.5" LCD Color Monitor AOC e2236Vw II. HDCP Write Step: Step1. Double click “HDCP20091026.exe” Step2. Click “Load HDCP…”. choose the corresponding “*.BIN” by scaler IC (MST Scaler) ,then click “Open” as below. 57 21.5" LCD Color Monitor AOC e2236Vw Step3. Pls choose the item remarked in red (i.e.: New CMD/Only Connect One Monitor/MST Scaler), then click “Start” to write HDCP, when display “Monitor 1 PASS” means Write OK. 58 21.5" LCD Color Monitor AOC e2236Vw III. Check HDCP. USE “Blu-Ray Disc” DVD to check whether the monitor with DVI connector displays normally. If error message appeared “ ” as below: 1. Check whether the HDCP writer is correct. 2. Check whether the tool is correct or not, and check the connection between PC, Monitor and tool. In addition, check whether the tool’s power supply is available. 3. If still no work, pls modify the “config.ini” as below, and then try again. Modify Step: Right click “config.ini”-> Open with “Notepad”->”OK”-> Modify the HDCP value (350->500, 150->300, 500->700)->Save. PS: You can also open “config.ini” directly if you have opened it through “Open with ‘Notepad’ ” before. 59 21.5" LCD Color Monitor AOC e2236Vw 60 21.5" LCD Color Monitor AOC e2236Vw 350 ->500 150 ->300 500 ->700 61 21.5" LCD Color Monitor AOC e2236Vw 9.2 DDC Instruction Tool list: 1. DDC board:715GT034-B 2. Software (WA.DAT&WD.DAT&*. CONFIG.INI) 3. LPT driver software 4. LPT cable, D-SUB CABLE ,DVI CABLE and DVI to HDMI CABLE 5. 12V( Adapter) 6. TPVDDCHDMI and TPVDDC6.0 7. PC 8. For example:e2239Fwt Tool picture For VGA&DVI BURNING: DDC Board as the follow picture: TO PC LPT DC 12V power VGA LCD DVI port DVI Install software: Note:Burning softsare and EDID data must be put in the same folder as follow picture: 62 21.5" LCD Color Monitor AOC e2236Vw VGA&DVI Burning: 1.Double-click the icon “ Double-click ” to install Port95nt print driver, and then restart the computer. , select “Analog and DVI” show as follow picture 2. Click “Load file” and select as follow picture.then click “LCDDDC” EX: DDCModelName:CHIMEI96VS 63 21.5" LCD Color Monitor AOC e2236Vw 3. Click “ok” show as follow picture. 4.Input same SN twice and date. Click “Pragram” to burn. When appear “pass” as follow picture that burning is successful. 64 21.5" LCD Color Monitor AOC e2236Vw 5. Click “program”, Note: . Appear fault as follow , please input SN twice and burning again. 65 21.5" LCD Color Monitor AOC e2236Vw When appear “pass” as follow picture that burning is successful. Click “Read both” show as follow picuture..If read SN and model name are same as before inputing as before that burning is successful. 66 21.5" LCD Color Monitor AOC e2236Vw Appear fault as follow, please check the connection of LPT cable , Tool adapter cable and LCD power. Appear fault as follow,please check the connection of VGA and the connection of DVI Note: If the burn software is unsuccessfulll, appear fault: 1. For VGA,the resolution will be not the best achieve. 2. For DVI,No picture,no sound. If program failed, in VGA mode, you can’t use the optimal resolution. 67 21.5" LCD Color Monitor AOC e2236Vw When Read is OK, program is NG, pls do take following action: 1. For VGA,cut off the 9th pin (connect the monitor). 2. For DVI, cut off the 14th pin (the shortest pin, power supply). 3. Connect the EEPROM WP pin to ground. 68 21.5" LCD Color Monitor 10. White- Balance, Luminance Adjustment AOC e2236Vw Approximately 30 minutes should be allowed for warm up before proceeding White-Balance adjustment. 1. How to do the Chroma-7120 MEM. Channel setting A. Reference to chroma 7120 user guide B. Use “ SC” key and “ NEXT” key to modify x, y, Y value and use “ID” key to modify the TEXT description Following is the procedure to do white-balance adjust 2. Setting the color temp. you want A. MEM.CHANNEL 3 (6500K color): 6500K color temp. parameter is x = 313 ±30, y = 329 ±30, Y = 200 cd/m2 B. MEM.CHANNEL 4 (7300K color): 7300K color temp. parameter is x = 302 ±30, y = 318 ±30, Y = 180 cd/m2 , C. MEM.CHANNEL 9 (9300K color): 9300K color temp. parameter is x = 283 ±30, y = 297 ±30, Y = 170 cd/m2 D. MEM.CHANNEL 10 (SRGB color): SRGB color temp. parameter is x = 313 ±30, y = 329 ±30, Y = 180 cd/m2 3. Enter into the factory mode: Turn off the power, then press ∧ key,∨ key and press the Power button at the same time, the next, press the Menu button, You will enter into the factory mode. 4. Bias adjustment: Set the Contrast to 50; Adjust the Brightness to 90. 5. Gain adjustment: Move cursor to “-F-” and press MENU key A. Adjust Warm (6500K) color-temperature 1. Switch the chroma-7120 to RGB-Mode (with press “MODE” button) 2. Switch the MEM.channel to Channel 3 (with up or down arrow on chroma 7120) 3. The LCD-indicator on chroma 7120 will show x = 313 ±30, y = 329 ±30, Y = 200 cd/m2 4. Adjust the RED on factory window until chroma 7120 indicator reached the value R=100 5. Adjust the GREEN on factory window until chroma 7120 indicator reached the value G=100 6. Adjust the BLUE on factory window until chroma 7120 indicator reached the value B=100 7. Repeat above procedure (item 4,5,6) until chroma 7120 RGB value meet the tolerance =100±5 B. Adjust Normal (7300K) color-temperature 1. Switch the Chroma-7120 to RGB-Mode (with press “MODE” button) 2. Switch the MEM. Channel to Channel 4 (with up or down arrow on chroma 7120) 3. The LCD-indicator on chroma 7120 will show x = 302 ±30, y = 318 ±30, Y = 180 cd/m2 4. Adjust the RED on factory window until chroma 7120 indicator reached the value R=100 5. Adjust the GREEN on factory window until chroma 7120 indicator reached the value G=100 6. Adjust the BLUE on factory window until chroma 7120 indicator reached the value B=100 7. Repeat above procedure (item 4,5,6) until chroma 7120 RGB value meet the tolerance =100±5 C. Adjust Cool (9300K) color-temperature 1. Switch the chroma-7120 to RGB-Mode (with press “MODE” button) 69 21.5" LCD Color Monitor AOC e2236Vw 2. Switch the MEM.channel to Channel 9(with up or down arrow on chroma 7120) 3. The LCD-indicator on chroma 7120 will show x = 283 ±30, y = 297 ±30, Y = 170 cd/m2 4. Adjust the RED on factory window until chroma 7120 indicator reached the value R=100 5. Adjust the GREEN on factory window until chroma 7120 indicator reached the value G=100 6. Adjust the BLUE on factory window until chroma 7120 indicator reached the value B=100 7. Repeat above procedure (item 4,5,6) until chroma 7120 RGB value meet the tolerance =100±5 D. Adjust SRGB color-temperature 1. Switch the chroma-7120 to RGB-Mode (with press “MODE” button) 2. Switch the MEM.channel to Channel 10(with up or down arrow on chroma 7120) 3. The LCD-indicator on chroma 7120 will show x = 313 ±30, y = 329 ±30, Y = 180 cd/m2 4. Adjust the RED on factory window until chroma 7120 indicator reached the value R=100 5. Adjust the GREEN on factory window until chroma 7120 indicator reached the value G=100 6. Adjust the BLUE on factory window until chroma 7120 indicator reached the value B=100 7. Repeat above procedure (item 4,5,6) until chroma 7120 RGB value meet the tolerance =100±5 E. Turn the Power-button off to quit from factory mode. 70 21.5" LCD Color Monitor 11.Mechanical Instructions AOC e2236Vw 1.Put the monitor on the EPE pad. 2.Lay down the monitor, then use cross screwdriver or the expert tools leave off the stand while press the Push area of the back cover. 3.Overturn the monitor and the top towards to us. 71 21.5" LCD Color Monitor AOC e2236Vw 4.Take apart the front frame with hands on the label area. 5.As the center of one side of USB connector, take apart 3 sides and stop. Attention: Do not break off the key pc side, or pull the front frame forcibly, to avoid the keypad peel off. 6.Overturn the monitor, on the USB connector area, one hand press the Panel, and use the other to undrawn the back cover. 72 21.5" LCD Color Monitor AOC e2236Vw 7.Make the notice that the front frame of the key pc side should be separated at last. 8. In turn to take apart the key pc connect PIN (A&B), lamp line (C&D), peel off the aluminum foil (E&F), draw off the FFC pin (G), if there is defect with main pc, need leave of f the six-angle screw (H). 9.Withdraw the front frame from the Panel side. Use screwdriver to take off the screw which used to fix the iron frame and Panel, and then take apart them. 73 21.5" LCD Color Monitor AOC e2236Vw 10. According to the different defective area, take off the screws ABCDE to get the relevant part to maintain. Before take apart the POWER pc should take off the AC iron piece first. 11. Use little screwdriver to peel off the key pc from the front frame when need maintain it. 74 21.5" LCD Color Monitor 12. Monitor Exploded View AOC e2236Vw 75 21.5" LCD Color Monitor 13. BOM List AOC e2236Vw Note: The parts information listed below are for reference only, and are subject to change without notice. Please go to http://cs.tpv.com.cn/hello1.asp for the latest information. TIAASL2E6WA1BNE Location HDCP-L E08907 E09503 E09503 E09503 E09504 E09504 E750 E08907 Part NO. 052G 1208 A 052G 1211 B 052G 2191 A 070GHDCP500HDC 089G179J30NA05 095G8014 7DW01 095G8014 7TW01 095G8014 7WW01 095G8022 6TE05 095G8022 6WE05 0D1G1730 8120 0M1G 130 6120 705GH934025 750GBU215H1B2HN000 A15G0647702 A34G1160AEDC1B0130 A34G1161AEDA6S0100 A85G0140101MCM ADPC91503HD4 CBPCBA8A1H7 H12G6200 10 H40G 45762413B H40G 58161569A H40G 58261531A H40G 58261537B H44GB005102 H44GB005202 H44GB005615 6C H45G 77 6 H45G 87 18 12 H70G200961532E KEPCBHA8 LNPCAB541AHD1 Q12G6600 6 Q40G 58162435A Q45G 76 28 H A Q45G 76 28V13 A Q50G 4 10 Q52G 1185 99 Q52G6019 14 S89G179T30NA05 USB9HA1 USBAHA5 0Q1G1740 12120 A34G1064AED 1S0100 A34G1065ABJ 1S0100 A34G1162AED 2S0130 A37G0108 3 H01G6006 1 756GHACB A1105 Description AL FOIL Conductive Tape 85mm *40mm *0.09mm PAPER TAPE HDCP CODE FFC CABLE 30 206 1.0 HARNESS 7P(2008)--6P(1005) 470 HARNESS 7P(2008)-6P(1005) 470MM HARNESS 7P(2008)-6P(1005) 470 HARNESS 6P(CI1406)-6P(1253) 400 HARNESS 6P(CI1406)-6P(1253) 400MM SCREW 3x8 SCREW M3X6 21.5"LCD STAND-BASE ASS'Y LCD M215HW01 VBTB WH AUO MAIN_FRAME BEZEL REAR COVER21.5" AC Shield ADAPTER G3189-P02-LED-X-2-100525 CONVERSION G3329-1-2-X-2-111103 RUBBER PAD P/N LABEL FOR BASE USB LABEL WIN7 EPA LABEL e936Vw POP LABEL EPS EPS e2236Vw CARTON PE PACKING EPE_COVER_MONITOR e2236Vw CD MANUAL KEY G3371-2-X-X-1-110616 CONVERTER G4137-P01-X-4-100826 FOOT LABEL P.E. BAGx320x210x0.04 PE BAG TIE (Y1900221) BIG CARTON TAPE FOR AOC TAPE FFC CABLE 30P 205mm P1.0MM USB G2663-2-X-X-1-090313 USB G3501-2-X-X-1-090313 SCREW Stand-Front Stand-Back BASE HINGE 22 Screw MCU ASS'Y 76 Remark 2nd source 2nd source 2nd source 2nd source 21.5" LCD Color Monitor U402 U402 SMTCA-U402 E08905 E08905 E08902 E08902 E08902 E08903 E08903 E08903 E08901 E08901 E08905 E08905 E08902 E08902 E08902 E08903 E08903 E08903 E08901 E08901 E08905 E08905 E08902 E08902 E08902 E08903 E08903 E08903 E08901 E08901 E08905 E08905 E08902 E08902 E08902 056G1133137 056G2233501 100GAMAI036W11 808GE2236VWAUS 089G 175 8A C 089G 175 8A G 089G 715CAAE01 089G 715GAAE01 089G 715HAAE01 089G1745CAA 9 089G1745GAA 9 089G1745HAA 9 089G412A15NHL3 089G412A15NIS3 H40G 001624 1A H40G 22N61534A H40G000261587A H41G780061558C 808GE2236VWHKG 089G 175 8A C 089G 175 8A G 089G 715CAAE01 089G 715GAAE01 089G 715HAAE01 089G1745CAA 9 089G1745GAA 9 089G1745HAA 9 089G410A15N HL 089G410A15N IS H40G 001624 1A H40G 22N61534A H40G000261587A H41G780961529A 808GE2236VWINA 026G 800504 H 089G 175 8A C 089G 175 8A G 089G 715CAAE01 089G 715GAAE01 089G 715HAAE01 089G1745CAA 9 089G1745GAA 9 089G1745HAA 9 089G404A15N HL 089G404A15N IS H40G 22N61556A H40G 58361596A H40G000261587A H41G1800615 1B H41G780061583A 808GE2236VWPHI 089G 175 8A C 089G 175 8A G 089G 715CAAE01 089G 715GAAE01 089G 715HAAE01 AOC e2236Vw IC MX25L2026MI-12G SOP-8 FLASH MX25L2026DM1I-12G 2Mb SOP-8 AOC_e2236vw_AUO E2236VW Australia ASS'Y USB CABLE 1800MM without PE bag USB CABLE 1800MM without PE bag SIGNAL CABLE SIGNAL CABLE SIGNAL CABLE DVI CABLE 1500 DVI CABLE DVI CABLE 1.5M AC POWER CORD 1500mm AC POWER CORD 1500mm CARTON LABEL BARCODE 1 ID LABEL AP BOXSTIKER LABEL Australia warranty E2236VW HongKong ASS'Y USB CABLE 1800MM without PE bag USB CABLE 1800MM without PE bag SIGNAL CABLE SIGNAL CABLE SIGNAL CABLE DVI CABLE 1500 DVI CABLE DVI CABLE 1.5M AC POWER CORD 1500 AC POWER CORD 1500 CARTON LABEL BARCODE 1 ID LABEL AP BOXSTIKER LABEL AP WARRANTY booklist E2236VW Indonesia ASS'Y BAR CODE LABEL USB CABLE 1800MM without PE bag USB CABLE 1800MM without PE bag SIGNAL CABLE SIGNAL CABLE SIGNAL CABLE DVI CABLE 1500 DVI CABLE DVI CABLE 1.5M AC POWER CORD 1500mm AC POWER CORD 1500 e2236Vw ID LABEL-Indonesia e2236Vw INA CARTON LABEL B AP BOXSTIKER LABEL manual--Indonesia warranty card--Indonesia E2236VW Philippines ASS'Y USB CABLE 1800MM without PE bag USB CABLE 1800MM without PE bag SIGNAL CABLE SIGNAL CABLE SIGNAL CABLE 77 2nd source 2nd source 2nd source 2nd source 2nd source 2nd source 2nd source 2nd source 2nd source 2nd source 2nd source 2nd source 2nd source 2nd source 2nd source 2nd source 2nd source 2nd source 2nd source 2nd source 2nd source 2nd source 21.5" LCD Color Monitor E08903 E08903 E08903 E08901 E08901 E08905 E08905 E08902 E08902 E08902 E08903 E08903 E08903 E08901 E08901 E08905 E08905 E08902 E08902 E08902 E08903 E08903 E08903 E08901 E08905 E08905 E08902 E08902 E08902 E08903 E08903 E08903 E08901 E08901 E08905 089G1745CAA 9 089G1745GAA 9 089G1745HAA 9 089G402A15N HL 089G402A15N IS H40G 001624 1A H40G 22N61534A H40G000261587A H41G780961529A 808GE2236VWTHA 089G 175 8A C 089G 175 8A G 089G 715CAAE01 089G 715GAAE01 089G 715HAAE01 089G1745CAA 9 089G1745GAA 9 089G1745HAA 9 089G402A15N HL 089G402A15N IS H40G 001624 1A H40G 22N61534A H40G000261587A H41G780961530A 808GE2236VWTPE 026G 800504 H 089G 175 8A C 089G 175 8A G 089G 715CAAE01 089G 715GAAE01 089G 715HAAE01 089G1745CAA 9 089G1745GAA 9 089G1745HAA 9 089G420A15N IS H40G 22N61546A H40G 58261572A H40G 58261573B H40G000261587A H41G780961540A 808GE2236VWUAE 089G 175 8A C 089G 175 8A G 089G 715CAAE01 089G 715GAAE01 089G 715HAAE01 089G1745CAA 9 089G1745GAA 9 089G1745HAA 9 089G404A15N HL 089G404A15N IS H40G 001624 1A H40G 22N61534A H41G780961529A 808GE2236VWVIE 089G 175 8A C AOC e2236Vw DVI CABLE 1500 DVI CABLE DVI CABLE 1.5M AC POWER CORD 1500mm AC POWER CORD 1500MM CARTON LABEL BARCODE 1 ID LABEL AP BOXSTIKER LABEL AP WARRANTY booklist E2236VW Thailand ASS'Y USB CABLE 1800MM without PE bag USB CABLE 1800MM without PE bag SIGNAL CABLE SIGNAL CABLE SIGNAL CABLE DVI CABLE 1500 DVI CABLE DVI CABLE 1.5M AC POWER CORD 1500mm AC POWER CORD 1500MM CARTON LABEL BARCODE 1 ID LABEL AP BOXSTIKER LABEL AOC warranty card--Thailand E2236VW taiwan ASS'Y BAR CODE LABEL USB CABLE 1800MM without PE bag USB CABLE 1800MM without PE bag SIGNAL CABLE SIGNAL CABLE SIGNAL CABLE DVI CABLE 1500 DVI CABLE DVI CABLE 1.5M AC POWER CORD 1500MM TAIWAN ID LABEL AOC TW WARRANTY LABEL carton label AP BOXSTIKER LABEL TW WARRANTY BOOKLIST e2236Vw United Arab Emirates ASS'Y USB CABLE 1800MM without PE bag USB CABLE 1800MM without PE bag SIGNAL CABLE SIGNAL CABLE SIGNAL CABLE DVI CABLE 1500 DVI CABLE DVI CABLE 1.5M AC POWER CORD 1500mm AC POWER CORD 1500 CARTON LABEL BARCODE 1 ID LABEL AP WARRANTY booklist E2236VW Vietnam ASS'Y USB CABLE 1800MM without PE bag 78 2nd source 2nd source 2nd source 2nd source 2nd source 2nd source 2nd source 2nd source 2nd source 2nd source 2nd source 2nd source 2nd source 2nd source 2nd source 2nd source 2nd source 2nd source 2nd source 2nd source 21.5" LCD Color Monitor E08905 E08902 E08902 E08902 E08903 E08903 E08903 E08901 E08901 GND1 GND2 GND3 CN903 IC902 NR901 C904 C902 C903 C900 C918 C907A C912 C914 L901 L902 L903 T901 CN901 D903 D905 D904 D906 CN902 CN902 E09502 E09502 BD901 CN402 CN701 CN301 R708 CN101 CN102 X401 C802 089G 175 8A G 089G 715CAAE01 089G 715GAAE01 089G 715HAAE01 089G1745CAA 9 089G1745GAA 9 089G1745HAA 9 089G404A15N HL 089G404A15N IS H40G 001624 1A H40G 22N61534A H40G000261587A Q41G78D161522A 009G6005 1 009G6005 1 009G6005 1 033G380210B Y L 056G 139 3A 061G 58100 X 063G107K2246S1 065G306K3312B3 065G306K3312B3 065G306M1022BP 067G 3151007KV 067G 40Z10115L 067G215D6814LV 067G215S4713KV 073G 174 65 H2 073G 253 91 H 073G 253 91 H 080GL19P 1 N 087G 501 32 DL 093G 60335 093G 60335 093G 60923 093G 60923 095G 825 9DE08 095G 825 9XE08 095G801410DE06 095G801410TE06 705GH956024 709G3189 HM001 H40G 45762429A 093G 50460514 033G3802 7B Y L 033G3802 9B Y L 033G801930F CH JS 061G152M33964L SY 088G 35315F CH 088G 35424F CH 093G 2253B J 709G3329 HM003 H40G 45762429A A33G0564 2 1L0100 H52G1201 1 067G 4151017LV AOC e2236Vw USB CABLE 1800MM without PE bag SIGNAL CABLE SIGNAL CABLE SIGNAL CABLE DVI CABLE 1500 DVI CABLE DVI CABLE 1.5M AC POWER CORD 1500mm AC POWER CORD 1500 CARTON LABEL BARCODE 1 ID LABEL AP BOXSTIKER LABEL Vietnam warranty GND TERMINAL GND TERMINAL GND TERMINAL CONNECTOR 10P 2.0 PC123Y22FZOF SHARP NTCR 10R 20% 5W(10D2-14 MCS) X2 CAP 0.22UF K 275VAC Y1 CAP 330PF K 250VAC CD Y1 CAP 330PF K 250VAC CD CAP Y1 1NF 20% 250V Y5U CAP 105C 10UF M 50V EC 100uF 450V M 18*35.5mm LOW ESR EC 680uF 25V M 10*20mm EC 470UF 20% 16V 10X13 LINE FILTER 30mH MIN IND CHOKE 3.5uH+-10% DADONG IND CHOKE 3.5uH+-10% DADONG X'FMR 1.1mH 10% 20uH MAX YUVA-1208 AC SOCKET DIP 3PIN+2PIN GROUND DIODE SR515 5A/150V DO-201AD DIODE SR515 5A/150V DO-201AD DIODE SR504-30 DO-201AD DIODE SR504-30 DO-201AD HARNESS 9P-9P 200MM HARNESS 9P-9P 200MM HARNESS 10P(1253)-10P(PLUG) 310MM HARNESS 10P(1253)-10P(PLUG) 310MM IC901 ASS'Y COMSUPTIVE ASS'Y LABEL BRIDGE KBP306G-05 3A 800V KBP CONNECTOR 7P 2.0 CONN 2.0 9P FFC CONN 1.0mm 30P R/A 34mm 6.3mm RST MOFR 3.3 OHM +-5% 2WS SHANG YU D-SUB CONN WITH SCREW 15P DVI 24PIN CONN F ATTACHED SCREW NXS14.31818AC32F-KAB10 CONSUMPTIVE ASS'Y LABEL Key-Guide 3M DOUBLE FACE TAPE EC 100uF 20% 50V RZY 8*11.5 79 2nd source 2nd source 2nd source 2nd source 2nd source 2nd source 2nd source 2nd source 21.5" LCD Color Monitor C804 CN511 CN512 CN501 CN502 E09508 E09508 E09508 IC901 HS1 R623 R628 R917 R913 R912 R916 R915 R923 R903 R924 R925 R927 R910 R926 R909 R908 R907 R906 R905 R904 R920 R921 R922 R900 R901 R902 C916 C905 C915 C917 C901 C910 C911 C919 C920 067G415L330 9L 709G3823 HM001 H40G 45762429A 033G3802 5 BH 088G 352 2 XH 709G2663 HM002 715G2663 3 033G3802 5B Y 088G 351 2B XH 095G8014 5DH09 095G8014 5TH09 095G8014 5WH09 709G3501 HM001 056G 581 20 0M1G 930 8120 Q11G0026 1 Q90G6263 6 Q51G 6 4509 Q55G 100625 061G0603000 JF 061G0603000 JF 061G06031001FT 061G06031002FT 061G0603103 JT 061G0603471 JT 061G06039311FT 061G0805103 JT 061G08051102FT 061G0805689 JT 061G08058202FT 061G12060004JT 061G1206101 JT 061G1206229 JT 061G1206300 JT 061G1206300 JT 061G1206300 JT 061G1206300 JT 061G1206300 JT 061G1206300 JT 061G1206335 JT 061G1206335 JT 061G1206335 JT 061G1206624 JT 061G1206624 JT 061G1206624 JT 065G060310312K 065G080510432K 065G080510432K 065G080510432K 065G080582031J 065G120622272K 065G120622272K 065G120622272K 065G120622272K 709G3189 HS001 Q55G 100625 AOC e2236Vw L L F F Y Y F Y Y Y Y EC 33UF 20% 100V 8*11.5 COMSUPTIVE ASS'Y LABEL CONNECTOR 5PIN USB CONN A TYPE 4P CONSUMPTIVE ASS'Y USB BOARD PCB CONNECTOR 5P 2.0 USB CONN B TYPE 4P HARNESS 5P(PH)-5P(PLUG) 180MM HARNESS 5P(PLUG)-5P(2501) 180MM HARNESS 5P(PLUG)-5P(2501) 180MM CONSUMPTIVE ASS'Y IC TOP255EN eSIP-7C SCREW 3x8 WIRE-CLIP HEAT SINK GLUE_RTV TIN STICK_LOW ARGENTUM RST CHIPR MAX 0R05 1/10W FENGHUA RST CHIPR MAX 0R05 1/10W FENGHUA RST CHIP 1K 1/10W 1% RST CHIP 10K 1/10W 1% RST CHIP 10K 1/10W 5% TZAI YUAN RST CHIPR 470OHM +-5% 1/10W TZAI YUAN RST CHIPR 9.31k 1% 1/10W RST 0805 10K 5% 1/8W RST CHIP 11K 1/8W 1% RST CHIPR 6.8 OHM +-5% 1/8W 0805 RST CHIPR 82K +-1% 1/8W TZAI YUAN RST CHIPR 1206 MAX0R05 4A 1/4W TZAI YUAN RST CHIPR 100 OHM +-5% 1/4W TZAI YUAN RST CHIPR 2R2 +-5% 1/4W TZAI YUAN RST CHIPR 30 OHM +-5% 1/4W TZAI YUAN RST CHIPR 30 OHM +-5% 1/4W TZAI YUAN RST CHIPR 30 OHM +-5% 1/4W TZAI YUAN RST CHIPR 30 OHM +-5% 1/4W TZAI YUAN RST CHIPR 30 OHM +-5% 1/4W TZAI YUAN RST CHIPR 30 OHM +-5% 1/4W TZAI YUAN RST CHIPR 3.3 MOHM +-5% 1/4W TZAI YUAN RST CHIPR 3.3 MOHM +-5% 1/4W TZAI YUAN RST CHIPR 3.3 MOHM +-5% 1/4W TZAI YUAN RST CHIPR 620 KOHM +-5% 1/4W TZAI YUAN RST CHIPR 620 KOHM +-5% 1/4W TZAI YUAN RST CHIPR 620 KOHM +-5% 1/4W TZAI YUAN NO-SUGGEST 0603 10NF K 16V X7R CAP CHIP 0805 0.1UF K 50V X7R CAP CHIP 0805 100N 50V X7R +/-10% CAP CHIP 0805 100N 50V X7R +/-10% CAP CHIP 0805 82PF J 50V NPO CER 1206 2N2 500V X7R 10% CER 1206 2N2 500V X7R 10% CER 1206 2N2 500V X7R 10% CER 1206 2N2 500V X7R 10% COMSUPTIVE ASS'Y TIN STICK_LOW ARGENTUM 80 2nd source 2nd source 21.5" LCD Color Monitor C419 C707 C704 C305 U401 U703 U701 U107 U106 U105 U104 U103 U101 U102 U402 U402 Q401 Q302 Q701 Q405 Q301 R414 R418 R419 R423 R434 R452 R134 R132 R131 R130 R129 R128 R127 R126 R119 R409 R415 R416 R417 R422 R424 R428 R706 R118 R117 R115 R114 R113 R111 R109 R105 R101 R705 R404 067G 3151007KB 067G 3151014KB 067G 3151014KB 067G 3151014KB 709G3329 HA003 056G 562F31 056G 563 31 056G 585 4A 056G 662 48 056G 662 48 056G 662 48 056G 662 48 056G 662 48 056G1133 34 056G1133 34 056G1133137 056G2233501 057G 417518 057G 417518 057G 417518 057G 417526 057G 763 1 061G0402000 JF 061G0402000 JF 061G0402000 JF 061G0402000 JF 061G0402000 JF 061G0402000 JF 061G0402100 JF 061G0402100 JF 061G0402100 JF 061G0402100 JF 061G0402100 JF 061G0402100 JF 061G0402100 JF 061G0402100 JF 061G0402101 JF 061G0402101 JF 061G0402101 JF 061G0402101 JF 061G0402101 JF 061G0402101 JF 061G0402101 JF 061G0402101 JF 061G0402101 JF 061G0402101 JF 061G0402101 JF 061G0402101 JF 061G0402101 JF 061G0402101 JF 061G0402101 JF 061G0402101 JF 061G0402101 JF 061G0402101 JF 061G0402102 JF 061G0402102 JF AOC e2236Vw EC 10uF M 50V 5*11mm EG EC LOW ESR 100UF M 25V 6.3*11mm EG EC LOW ESR 100UF M 25V 6.3*11mm EG EC LOW ESR 100UF M 25V 6.3*11mm EG CONSUMPTIVE ASS'Y SCALER TSUMU58PWHL-LF-1 100PIN FQFP IC AZ1117D-1.8-E1 AP1117E33L-13-77 1A 3.3V SOT-223 ESD PROTECT AZC399-04S.R7G SOT23-6L ESD PROTECT AZC399-04S.R7G SOT23-6L ESD PROTECT AZC399-04S.R7G SOT23-6L ESD PROTECT AZC399-04S.R7G SOT23-6L ESD PROTECT AZC399-04S.R7G SOT23-6L EEPROM M24C02-WMN6TP 2Kb SO-8 EEPROM M24C02-WMN6TP 2Kb SO-8 IC MX25L2026MI-12G SOP-8 FLASH MX25L2026DM1I-12G 2Mb SOP-8 TRA LMBT3904LT1G 200mA/40V SOT-23 LRC TRA LMBT3904LT1G 200mA/40V SOT-23 LRC TRA LMBT3904LT1G 200mA/40V SOT-23 LRC SMALLTRAN MMBT3906 -0.2A -40V SOT-23 MOSFET A03401 4.2A 30V SOT-23 RST CHIPR MAX0R05 1/16W FENGHUA RST CHIPR MAX0R05 1/16W FENGHUA RST CHIPR MAX0R05 1/16W FENGHUA RST CHIPR MAX0R05 1/16W FENGHUA RST CHIPR MAX0R05 1/16W FENGHUA RST CHIPR MAX0R05 1/16W FENGHUA RST CHIPR 10 OHM +-5% 1/16W FENGHUA RST CHIPR 10 OHM +-5% 1/16W FENGHUA RST CHIPR 10 OHM +-5% 1/16W FENGHUA RST CHIPR 10 OHM +-5% 1/16W FENGHUA RST CHIPR 10 OHM +-5% 1/16W FENGHUA RST CHIPR 10 OHM +-5% 1/16W FENGHUA RST CHIPR 10 OHM +-5% 1/16W FENGHUA RST CHIPR 10 OHM +-5% 1/16W FENGHUA RST CHIPR 100 OHM +-5% 1/16W FENGHUA RST CHIPR 100 OHM +-5% 1/16W FENGHUA RST CHIPR 100 OHM +-5% 1/16W FENGHUA RST CHIPR 100 OHM +-5% 1/16W FENGHUA RST CHIPR 100 OHM +-5% 1/16W FENGHUA RST CHIPR 100 OHM +-5% 1/16W FENGHUA RST CHIPR 100 OHM +-5% 1/16W FENGHUA RST CHIPR 100 OHM +-5% 1/16W FENGHUA RST CHIPR 100 OHM +-5% 1/16W FENGHUA RST CHIPR 100 OHM +-5% 1/16W FENGHUA RST CHIPR 100 OHM +-5% 1/16W FENGHUA RST CHIPR 100 OHM +-5% 1/16W FENGHUA RST CHIPR 100 OHM +-5% 1/16W FENGHUA RST CHIPR 100 OHM +-5% 1/16W FENGHUA RST CHIPR 100 OHM +-5% 1/16W FENGHUA RST CHIPR 100 OHM +-5% 1/16W FENGHUA RST CHIPR 100 OHM +-5% 1/16W FENGHUA RST CHIPR 100 OHM +-5% 1/16W FENGHUA RST CHIPR 1KOHM +-5% 1/16W FENGHUA RST CHIPR 1KOHM +-5% 1/16W FENGHUA 81 2nd source 21.5" LCD Color Monitor R402 R104 R103 R703 R702 R436 R412 R407 R308 R305 R135 R133 R120 R421 R107 R106 R304 R406 R704 R401 R432 R433 R110 R303 R138 R137 R136 R125 R124 R123 R306 R139 R116 R112 R108 R102 R405 R461 R456 R301 R302 C107 C121 C122 C413 C414 C415 C416 C417 C422 C432 C701 C702 C705 C708 C709 061G0402102 JF 061G0402102 JF 061G0402102 JF 061G0402103 JF 061G0402103 JF 061G0402103 JF 061G0402103 JF 061G0402103 JF 061G0402103 JF 061G0402103 JF 061G0402103 JF 061G0402103 JF 061G0402103 JF 061G0402104 JF 061G0402222 JF 061G0402222 JF 061G0402223 JF 061G0402223 JF 061G0402223 JF 061G04023900FF 061G04023901FF 061G04023901FF 061G0402471 JF 061G0402472 JF 061G0402472 JF 061G0402472 JF 061G0402472 JF 061G0402472 JF 061G0402472 JF 061G0402472 JF 061G0402563 JF 061G0402682 JF 061G0402750 JF 061G0402750 JF 061G0402750 JF 061G0603000 JF 061G0603000 JF 061G0603000 JF 061G0603220 JF 061G1206221 JF 061G1206221 JF 065G040210232K 065G040210232K 065G040210232K 065G040210412K 065G040210412K 065G040210412K 065G040210412K 065G040210412K 065G040210412K 065G040210412K 065G040210412K 065G040210412K 065G040210412K 065G040210412K 065G040210412K AOC e2236Vw Y Y Y A A A A A A A A A A A A RST CHIPR 1KOHM +-5% 1/16W FENGHUA RST CHIPR 1KOHM +-5% 1/16W FENGHUA RST CHIPR 1KOHM +-5% 1/16W FENGHUA RST CHIPR 10KOHM +-5% 1/16W FENGHUA RST CHIPR 10KOHM +-5% 1/16W FENGHUA RST CHIPR 10KOHM +-5% 1/16W FENGHUA RST CHIPR 10KOHM +-5% 1/16W FENGHUA RST CHIPR 10KOHM +-5% 1/16W FENGHUA RST CHIPR 10KOHM +-5% 1/16W FENGHUA RST CHIPR 10KOHM +-5% 1/16W FENGHUA RST CHIPR 10KOHM +-5% 1/16W FENGHUA RST CHIPR 10KOHM +-5% 1/16W FENGHUA RST CHIPR 10KOHM +-5% 1/16W FENGHUA RST CHIPR 100KOHM +-5% 1/16W FENGHUA RST CHIPR 2.2KOHM +-5% 1/16W FENGHUA RST CHIPR 2.2KOHM +-5% 1/16W FENGHUA RST CHIPR 22KOHM 5% 1/16W FENGHUA RST CHIPR 22KOHM 5% 1/16W FENGHUA RST CHIPR 22KOHM 5% 1/16W FENGHUA RST CHIPR 390 OHM +-1% 1/16W FENGHUA RST CHIPR 3.9KOHM +-1% 1/16W FENGHUA RST CHIPR 3.9KOHM +-1% 1/16W FENGHUA RST CHIPR 470 OHM 5% 1/16W FENGHUA RST CHIPR 4.7KOHM +-5% 1/16W FENGHUA RST CHIPR 4.7KOHM +-5% 1/16W FENGHUA RST CHIPR 4.7KOHM +-5% 1/16W FENGHUA RST CHIPR 4.7KOHM +-5% 1/16W FENGHUA RST CHIPR 4.7KOHM +-5% 1/16W FENGHUA RST CHIPR 4.7KOHM +-5% 1/16W FENGHUA RST CHIPR 4.7KOHM +-5% 1/16W FENGHUA RST CHIPR 56KOHM 1/16W FENGHUA RST CHIPR 6.8KOHM +-5% 1/16W FENGHUA RST CHIPR 75 OHM +-5% 1/16W FENGHUA RST CHIPR 75 OHM +-5% 1/16W FENGHUA RST CHIPR 75 OHM +-5% 1/16W FENGHUA RST CHIPR MAX 0R05 1/10W FENGHUA RST CHIPR MAX 0R05 1/10W FENGHUA RST CHIPR MAX 0R05 1/10W FENGHUA ST CHIPR 22 OHM +-5% 1/10W FENGHUA RST CHIPR 220 OHM +-5% 1/4W FENGHUA RST CHIPR 220 OHM +-5% 1/4W FENGHUA CAP CHIP 0402 1N 50V X7R +/-10% CAP CHIP 0402 1N 50V X7R +/-10% CAP CHIP 0402 1N 50V X7R +/-10% CAP CHIP 0402 100nF K 16V X7R CAP CHIP 0402 100nF K 16V X7R CAP CHIP 0402 100nF K 16V X7R CAP CHIP 0402 100nF K 16V X7R CAP CHIP 0402 100nF K 16V X7R CAP CHIP 0402 100nF K 16V X7R CAP CHIP 0402 100nF K 16V X7R CAP CHIP 0402 100nF K 16V X7R CAP CHIP 0402 100nF K 16V X7R CAP CHIP 0402 100nF K 16V X7R CAP CHIP 0402 100nF K 16V X7R CAP CHIP 0402 100nF K 16V X7R 82 21.5" LCD Color Monitor C712 C713 C115 C124 C301 C304 C403 C404 C405 C406 C407 C408 C409 C410 C411 C412 C436 C103 C104 C116 C117 C302 C401 C421 C420 C114 C111 C110 C108 C106 C102 C113 C109 C105 C303 C402 FB301 FB410 FB404 FB402 FB401 FB110 FB105 FB104 FB103 FB102 FB101 D104 D108 ZD104 CN001 U001 R012 065G040210412K A 065G040210412K A 065G040210412K A 065G040210412K A 065G040210412K A 065G040210412K A 065G040210412K A 065G040210412K A 065G040210412K A 065G040210412K A 065G040210412K A 065G040210412K A 065G040210412K A 065G040210412K A 065G040210412K A 065G040210412K A 065G0402105A5K Y 065G040222031J Y 065G040222031J Y 065G040222415K Y 065G040222415K Y 065G040222415K Y 065G040222415K Y 065G040247031J Y 065G040247031J Y 065G040247312K Y 065G040247312K Y 065G040247312K Y 065G040247312K Y 065G040247312K Y 065G040247312K Y 065G040250931C Y 065G040250931C Y 065G040250931C Y 065G060310522K T 065G0805475A5K Y 071G 56K121 M 071G 56V301 M 071G 56V301 M 071G 56V301 M 071G 56V301 M 071G 59G301 EM 071G 59G301 EM 071G 59G301 EM 071G 59K190 M 071G 59K190 M 071G 59K190 M 093G 64 42 L 093G 64 42 L 093G 39GA01 T 709G3329 HS003 715G3329 1 2 H52G1701 1 033G8034 6H H L1 056G 669 10 061G0603000 JT AOC e2236Vw CAP CHIP 0402 100nF K 16V X7R CAP CHIP 0402 100nF K 16V X7R CAP CHIP 0402 100nF K 16V X7R CAP CHIP 0402 100nF K 16V X7R CAP CHIP 0402 100nF K 16V X7R CAP CHIP 0402 100nF K 16V X7R CAP CHIP 0402 100nF K 16V X7R CAP CHIP 0402 100nF K 16V X7R CAP CHIP 0402 100nF K 16V X7R CAP CHIP 0402 100nF K 16V X7R CAP CHIP 0402 100nF K 16V X7R CAP CHIP 0402 100nF K 16V X7R CAP CHIP 0402 100nF K 16V X7R CAP CHIP 0402 100nF K 16V X7R CAP CHIP 0402 100nF K 16V X7R CAP CHIP 0402 100nF K 16V X7R NO-SUGGEST CAP 0402 1UF 10% 10V X5R CAP CHIP 0402 22P 50V NP0 +/-5% CAP CHIP 0402 22P 50V NP0 +/-5% CAP CHIP 0402 220nF 16V X5R CAP CHIP 0402 220nF 16V X5R CAP CHIP 0402 220nF 16V X5R CAP CHIP 0402 220nF 16V X5R CAP 0402 47PF 5% 50V NP0 CAP 0402 47PF 5% 50V NP0 CAP 0402 47NF 10% 16V X7R CAP 0402 47NF 10% 16V X7R CAP 0402 47NF 10% 16V X7R CAP 0402 47NF 10% 16V X7R CAP 0402 47NF 10% 16V X7R CAP 0402 47NF 10% 16V X7R CAP 0402 5PF 0.25pF 50V NP0 CAP 0402 5PF 0.25pF 50V NP0 CAP 0402 5PF 0.25pF 50V NP0 CAP CHIP 0603 1uF K 25V X7R CAP CHIP 0805 4.7UF K 10V X5R CHIP BEAD 120OHM 6A MGLB2012-120T-LF CHIP BEAD 0805 300R 25% 700mA CHIP BEAD 0805 300R 25% 700mA CHIP BEAD 0805 300R 25% 700mA CHIP BEAD 0805 300R 25% 700mA CHIP BEAD 0603 300R 25% 200mA CHIP BEAD 0603 300R 25% 200mA CHIP BEAD 0603 300R 25% 200mA CHIP BEAD 0603 19R/500mA CHIP BEAD 0603 19R/500mA CHIP BEAD 0603 19R/500mA DIODE LBAV70LT1G SOT-23 LRC DIODE LBAV70LT1G SOT-23 LRC RLZ5.6B CONSUMPTIVE ASS'Y MAIN BOARD PCB MESH PRINTTING_PAPER CONN 1.0mm 6P R/A - TOUCH KEY CG7246AMT QFN-16(COL) RST CHIP MAX 0R05 1/10W TZAI YUAN 83 21.5" LCD Color Monitor R009 R008 R001 R002 R007 R006 R005 R004 C001 C002 LED001 ZD005 ZD004 CN805 CN801 IC801 Q801 R823 R857 R855 R849 R848 R844 R814 R807 R812 R810 R813 R806 R809 R829 R828 R827 R826 R830 R831 R832 R833 R805 R804 R824 R822 R825 R801 R847 R846 C816 C805 C810 C803 C801 C807 C806 L801 ZD801 061G0603000 JT 061G0603000 JT 061G0603000 JT 061G0603101 JT 061G0603561 JT 061G0603561 JT 061G0603561 JT 061G0603561 JT 065G060310231J 065G0603225A5K 081G15BY 2 GP 093G 39S 34 T 093G 39S 34 T 715G3371 2 033G8032 6F HR 033G803210F HR 056G 379185 057G 763 92 061G0603000 FF 061G0603000 JT 061G0603000 JT 061G0603000 JT 061G0603000 JT 061G0603100 JF 061G0603100 JF 061G0603100 JF 061G0603101 JT 061G0603102 JT 061G0603103 JT 061G0603103 JT 061G0603104 JT 061G0603109 JT 061G0603109 JT 061G0603109 JT 061G0603109 JT 061G0603109 JT 061G0603109 JT 061G0603109 JT 061G0603109 JT 061G0603124 JT 061G06032002FT 061G06033302FT 061G0805105 JT 061G1206000 JF 061G12061507FT 061G1206308 JF 061G1206308 JF 065G060310232K 065G060347412K 065G080510432K 065G080510432K 065G080510432K 065G080522525K 065G080522525K 073G253S 90 X 093G 60S907 T AOC e2236Vw Y A F Y F F F T T RST CHIP MAX 0R05 1/10W TZAI YUAN RST CHIP MAX 0R05 1/10W TZAI YUAN RST CHIP MAX 0R05 1/10W TZAI YUAN RST CHIP 100R 1/10W 5% TZAI YUAN RST CHIPR 560OHM +-5% 1/10W TZAI YUAN RST CHIPR 560OHM +-5% 1/10W TZAI YUAN RST CHIPR 560OHM +-5% 1/10W TZAI YUAN RST CHIPR 560OHM +-5% 1/10W TZAI YUAN CHIP 0603 1000pF 50V NPO CAP 0603 2.2UF K 10V X5R CHIP LED blue/yellow GPTD12048BOC1-A UDZSNP5.6B ROHM UDZSNP5.6B ROHM KEY BOARD PCB CONNECTOR 6P 1.25 CONNECTOR 10P 1.25 LED DRIVER TA9690GN-A1-0-TR SOP-24 FET P8008HV 4A/80V SOP-8 RST CHIPR MAX0R01 1/10W FENGHUA RST CHIP MAX 0R05 1/10W TZAI YUAN RST CHIP MAX 0R05 1/10W TZAI YUAN RST CHIP MAX 0R05 1/10W TZAI YUAN RST CHIP MAX 0R05 1/10W TZAI YUAN RST CHIPR 10 OHM 5% 1/10W FENGHUA RST CHIPR 10 OHM 5% 1/10W FENGHUA RST CHIPR 10 OHM 5% 1/10W FENGHUA RST CHIP 100R 1/10W 5% TZAI YUAN RST CHIP 1K 1/10W 5% TZAI YUAN RST CHIP 10K 1/10W 5% TZAI YUAN RST CHIP 10K 1/10W 5% TZAI YUAN RST CHIP 100K 1/10W 5% TZAI YUAN RST CHIP 1R 1/10W 5% TZAI YUAN RST CHIP 1R 1/10W 5% TZAI YUAN RST CHIP 1R 1/10W 5% TZAI YUAN RST CHIP 1R 1/10W 5% TZAI YUAN RST CHIP 1R 1/10W 5% TZAI YUAN RST CHIP 1R 1/10W 5% TZAI YUAN RST CHIP 1R 1/10W 5% TZAI YUAN RST CHIP 1R 1/10W 5% TZAI YUAN RST CHIP 120K 1/10W 5% TZAI YUAN RST CHIP 20K 1/10W 1% RST CHIP 33K 1/10W 1% RST CHIP 1M 1/8W 5% TZAI YUAN RST CHIPR MAX0R05 1/4W FENGHUA RST CHIPR 0.15 OHM +-1% 1/4W RST CHIPR 0.3 OHM +-5% 1/4W FENGHUA RST CHIPR 0.3 OHM +-5% 1/4W FENGHUA CAP CHIP 0603 1NF K 50V X7R CAP CHIP 0.47uF 16V +/-10% X7R CAP CHIP 0805 0.1UF K 50V X7R CAP CHIP 0805 0.1UF K 50V X7R CAP CHIP 0805 0.1UF K 50V X7R CAP CHIP 0805 2.2uF K 25V X5R CAP CHIP 0805 2.2uF K 25V X5R SMD CHOKE 22uH 3A HF SCHOTTKY B3100B 3A 100V SMB 84 21.5" LCD Color Monitor C503 C501 C502 FB501 CN901 IC903 Q901 R919 R918 C906 C913 C908 F901 F902 ZD902 ZD901 D902 D901 J906 J905 J904 J903 J902 J900 J616 J615 J609 J608 J601 715G4137P01000004S 065G060310432K A 065G060350931C Y 065G060350931C Y 071G 56K121 M 715G3501 3 006G 31500 056G 158 10 T 057G 530503 T 061G152M10452T SY 061G152M25152T SY 065G 2K152 2T6921 067G 2046812KT 067G 2154707NT 084G 55 5 084G 56 4W 093G 3916752T 093G 39A0852T 093G 6026T52T 093G 6038T52T 095G 90 23 095G 90 23 095G 90 23 095G 90 23 095G 90 23 095G 90 23 095G 90 23 095G 90 23 095G 90 23 095G 90 23 095G 90 23 709G3189 HA001 715G3189P02LED001S AOC e2236Vw CONVERTER BOARD PCB CAP 0603 100NF 10% 50V X7R CAP CHIP 0603 5P 50V NPO +/- 0.25PF CAP CHIP 0603 5P 50V NPO +/- 0.25PF CHIP BEAD 120OHM 6A MGLB2012-120T-LF USB BOARD PCB EYELET LDO IC AZ431AZ-AE1 TO-92 150MA 40V TO-92 2SD1207T RST MOFR 100KOHM +-5% 2WS FUTABA RST MOF 250R 5% 2W CAP CER 1500pF K 2KV Y5P CS CAP 680uF 10V 8*11 mm KY50VB47M-TP5 6.3*11 FUSE 2.5A 250V FUSE 4A 250V MTZJ T-72 16B GDZJ18B CTIFIER DIODE FR107 FR103 AO JUMPER WIRE JUMPER WIRE JUMPER WIRE JUMPER WIRE JUMPER WIRE JUMPER WIRE JUMPER WIRE JUMPER WIRE JUMPER WIRE JUMPER WIRE JUMPER WIRE COMSUPTIVE ASS'Y ADAPTER BOARD PCB 85