Download Magnavox 19MF301B Service manual
Transcript
19” LCD TV chassis FL11.0 SERVICE MANUAL Contents TYPE A 19MF301B/F7 MAGNAVOX (Serial No.: TH1) LC190EM2 EMERSON (Serial No.: TH1) LC190EM2 EMERSON (Serial No.: TH2) SYLVANIA (Serial No.: TH1) MAGNAVOX (Serial No.: DS2) TYPE B LC190SS2 TYPE C 19ME601B/F7 This service manual contains information of different types of models. Make sure to refer to the section describing your model. © 2011 Funai Electric Co., Ltd. All rights reserved. No part of this manual may be reproduced, copied, transmitted, disseminated, transcribed, downloaded or stored in any storage medium, in any form or for any purpose without the express prior written consent of Funai. Furthermore, any unauthorized commercial distribution of this manual or any revision hereto is strictly prohibited. Information in this document is subject to change without notice. Funai reserves the right to change the content herein without the obligation to notify any person or organization of such changes. with the design is a registered trademark of Funai Electric Co., Ltd and may not be used in any way without the express written consent of Funai. All other trademarks used herein remain the exclusive property of their respective owners. Nothing contained in this manual should be construed as granting, by implication or otherwise, any license or right to use any of the trademarks displayed herein. Misuse of any trademarks or any other content in this manual is strictly prohibited. Funai shall aggressively enforce its intellectual property rights to the fullest extent of the law. 110513 IMPORTANT SAFETY NOTICE Proper service and repair is important to the safe, reliable operation of all Funai Equipment. The service procedures recommended by Funai and described in this service manual are effective methods of performing service operations. Some of these service special tools should be used when and as recommended. It is important to note that this service manual contains various CAUTIONS and NOTICES which should be carefully read in order to minimize the risk of personal injury to service personnel. The possibility exists that improper service methods may damage the equipment. It also is important to understand that these CAUTIONS and NOTICES ARE NOT EXHAUSTIVE. Funai could not possibly know, evaluate and advice the service trade of all conceivable ways in which service might be done or of the possible hazardous consequences of each way. Consequently, Funai has not undertaken any such broad evaluation. Accordingly, a servicer who uses a service procedure or tool which is not recommended by Funai must first use all precautions thoroughly so that neither his safety nor the safe operation of the equipment will be jeopardized by the service method selected. The LCD panel is manufactured to provide many years of useful life. Occasionally a few non active pixels may appear as a tiny spec of color. This is not to be considered a defect in the LCD screen. TABLE OF CONTENTS Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-1 Important Safety Precautions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-1 Standard Notes for Servicing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-1 Cabinet Disassembly Instructions [TYPE A] . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-1 [TYPE B] . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-5 [TYPE C] . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-9 Electrical Adjustment Instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-1 How to Initialize the LCD TV . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-1 Firmware Renewal Mode . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-1 Troubleshooting [TYPE A] . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-1 [TYPE B] . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-6 [TYPE C] . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-15 Block Diagrams [TYPE A] . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9-1 [TYPE B] . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9-6 [TYPE C] . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9-12 Schematic Diagrams / CBA and Test Points . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10-1 Waveforms [TYPE A, TYPE C] . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11-1 [TYPE B] . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11-2 Wiring Diagram [TYPE A] . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12-1 [TYPE B] . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12-2 [TYPE C] . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12-3 Exploded Views. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13-1 Parts List [TYPE A] . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14-1 [TYPE B] . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14-10 [TYPE C] . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14-18 Revision History . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15-1 SPECIFICATIONS < TUNER / NTSC > ANT. Input ---------------------- 75 Ω Unbal., F type Description Condition 1. AFT Pull-In Range Unit Nominal Limit --- MHz ±2.3 ±2.1 TV.ch.4 CA.ch.31 CA.ch.87 dBµ dBµ dBµ 18 18 18 20 20 23 Condition Unit Nominal Limit --- kHz --- ±100 ch.4 ch.10 ch.41 dBm dBm dBm ------- -76/0 -76/0 -76/+4 Description Condition Unit Nominal Limit 1. Native Pixel Resolution Horizontal Vertical pixels pixels 1366 768 ----- --- cd/m2 280 [19MF301B/F7, LC190EM2, LC190SS2] 250 [19ME601B/F7] --- Horizontal Vertical ° ° -85 to 85 -80 to 80 ----- Condition Unit Nominal Limit Horizontal Vertical % % 5 5 5±5 5±5 --x y °K 12000 0.272 0.278 --±2% ±2% 2. Synchronizing Sens. < TUNER / ATSC > Description 1. Received Freq. Range (-28dBm) 2. ATSC Dynamic Range (min / max) < LCD PANEL > 2. Brightness (w / filter) 3. Viewing Angle < VIDEO > Description 1. Over Scan 2. Color Temperature 3. Resolution (composite video) <Measurement condition> Input signal: Internal pattern (40/70% raster) Measurement point: Screen center Measuring instrument: Made of KONICA MINOLTA Luminance meter CA-310 Aging time: 60min. (Retail MODE / 100IRE Raster HDMI 1080i@60) MODE setting of TV: Shipment setting / Retail MODE Ambient temperature: 25°C ±5°C Horizontal Vertical 1-1 line line 400 350 ----- FL11.0SP < AUDIO > All items are measured across 8 Ω load at speaker output terminal with L.P.F. Description Condition Unit 1. Audio Output (Volume MAX) 2. Audio Distortion (NTSC) 3. Audio Freq. Response (NTSC) Nominal Limit --- Lch/Rch W 1.5/1.5 [19MF301B/F7, LC190EM2, 19ME601B/F7] 3.0/3.0 [LC190SS2] 500mW: Lch/Rch % 0.5/0.5 2.0/2.0 -6dB: Lch -6dB: Rch Hz Hz 70 to 10 k 70 to 10 k ----- 1-2 FL11.0SP IMPORTANT SAFETY PRECAUTIONS Prior to shipment from the factory, our products are strictly inspected for recognized product safety and electrical codes of the countries in which they are to be sold. However, in order to maintain such compliance, it is equally important to implement the following precautions when a set is being serviced. Safety Precautions for LCD TV Circuit d. Leakage Current Hot Check - With the instrument completely reassembled, plug the AC line cord directly into a 120 V AC outlet. (Do not use an isolation transformer during this test.) Use a leakage current tester or a metering system that complies with American National Standards Institute (ANSI) C101.1 Leakage Current for Appliances and Underwriters Laboratories (UL) 1410, (50.7). With the instrument AC switch first in the on position and then in the off position, measure from a known earth ground (metal water pipe, conduit, etc.) to all exposed metal parts of the instrument (antennas, handle brackets, metal cabinet, screw heads, metallic overlays, control shafts, etc.), especially any exposed metal parts that offer an electrical return path to the chassis. Any current measured must not exceed 0.5 milli-ampere. Reverse the instrument power cord plug in the outlet and repeat the test. 1. Before returning an instrument to the customer, always make a safety check of the entire instrument, including, but not limited to, the following items: a. Be sure that no built-in protective devices are defective and have been defeated during servicing. (1) Protective shields are provided on this chassis to protect both the technician and the customer. Correctly replace all missing protective shields, including any removed for servicing convenience. (2) When reinstalling the chassis and/or other assembly in the cabinet, be sure to put back in place all protective devices, including but not limited to, nonmetallic control knobs, insulating fishpapers, adjustment and compartment covers/shields, and isolation resistor/capacitor networks. Do not operate this instrument or permit it to be operated without all protective devices correctly installed and functioning. Servicers who defeat safety features or fail to perform safety checks may be liable for any resulting damage. READING SHOULD NOT BE ABOVE 0.5 mA DEVICE BEING TESTED b. Be sure that there are no cabinet openings through which an adult or child might be able to insert their fingers and contact a hazardous voltage. Such openings include, but are not limited to, (1) spacing between the Liquid Crystal Panel and the cabinet mask, (2) excessively wide cabinet ventilation slots, and (3) an improperly fitted and/or incorrectly secured cabinet back cover. LEAKAGE CURRENT TESTER _ + TEST ALL EXPOSED METAL SURFACES ALSO TEST WITH PLUG REVERSED USING AC ADAPTER PLUG AS REQUIRED c. Antenna Cold Check - With the instrument AC plug removed from any AC source, connect an electrical jumper across the two AC plug prongs. Place the instrument AC switch in the on position. Connect one lead of an ohmmeter to the AC plug prongs tied together and touch the other ohmmeter lead in turn to each tuner antenna input exposed terminal screw and, if applicable, to the coaxial connector. If the measured resistance is less than 1.0 megohm or greater than 5.2 megohm, an abnormality exists that must be corrected before the instrument is returned to the customer. Repeat this test with the instrument AC switch in the off position. EARTH GROUND ANY MEASUREMENTS NOT WITHIN THE LIMITS SPECIFIED HEREIN INDICATE A POTENTIAL SHOCK HAZARD THAT MUST BE ELIMINATED BEFORE RETURNING THE INSTRUMENT TO THE CUSTOMER OR BEFORE CONNECTING THE ANTENNA OR ACCESSORIES. 2. Read and comply with all caution and safetyrelated notes on or inside the receiver cabinet, on the receiver chassis, or on the Liquid Crystal Panel. 2-1 LTVN_ISP 7. Product Safety Notice - Some electrical and mechanical parts have special safety-related characteristics which are often not evident from visual inspection, nor can the protection they give necessarily be obtained by replacing them with components rated for higher voltage, wattage, etc. Parts that have special safety characteristics are identified by a # on schematics and in parts lists. Use of a substitute replacement that does not have the same safety characteristics as the recommended replacement part might create shock, fire, and/or other hazards. The product's safety is under review continuously and new instructions are issued whenever appropriate. Prior to shipment from the factory, our products are strictly inspected to confirm they comply with the recognized product safety and electrical codes of the countries in which they are to be sold. However, in order to maintain such compliance, it is equally important to implement the following precautions when a set is being serviced. 3. Design Alteration Warning - Do not alter or add to the mechanical or electrical design of this TV receiver. Design alterations and additions, including, but not limited to circuit modifications and the addition of items such as auxiliary audio and/or video output connections, might alter the safety characteristics of this receiver and create a hazard to the user. Any design alterations or additions will void the manufacturer's warranty and may make you, the servicer, responsible for personal injury or property damage resulting therefrom. 4. Hot Chassis Warning a. Some TV receiver chassis are electrically connected directly to one conductor of the AC power cord and maybe safety-serviced without an isolation transformer only if the AC power plug is inserted so that the chassis is connected to the ground side of the AC power source. To confirm that the AC power plug is inserted correctly, with an AC voltmeter, measure between the chassis and a known earth ground. If a voltage reading in excess of 1.0 V is obtained, remove and reinsert the AC power plug in the opposite polarity and again measure the voltage potential between the chassis and a known earth ground. b. Some TV receiver chassis normally have 85V AC(RMS) between chassis and earth ground regardless of the AC plug polarity. This chassis can be safety-serviced only with an isolation transformer inserted in the power line between the receiver and the AC power source, for both personnel and test equipment protection. c. Some TV receiver chassis have a secondary ground system in addition to the main chassis ground. This secondary ground system is not isolated from the AC power line. The two ground systems are electrically separated by insulation material that must not be defeated or altered. 5. Observe original lead dress. Take extra care to assure correct lead dress in the following areas: a. near sharp edges, b. near thermally hot parts-be sure that leads and components do not touch thermally hot parts, c. the AC supply, d. high voltage, and, e. antenna wiring. Always inspect in all areas for pinched, out of place, or frayed wiring. Check AC power cord for damage. 6. Components, parts, and/or wiring that appear to have overheated or are otherwise damaged should be replaced with components, parts, or wiring that meet original specifications. Additionally, determine the cause of overheating and/or damage and, if necessary, take corrective action to remove any potential safety hazard. 2-2 LTVN_ISP Precautions during Servicing A. Parts identified by the # symbol are critical for safety. Replace only with part number specified. B. In addition to safety, other parts and assemblies are specified for conformance with regulations applying to spurious radiation. These must also be replaced only with specified replacements. Examples: RF converters, RF cables, noise blocking capacitors, and noise blocking filters, etc. C. Use specified internal wiring. Note especially: 1) Wires covered with PVC tubing 2) Double insulated wires 3) High voltage leads D. Use specified insulating materials for hazardous live parts. Note especially: 1) Insulation Tape 2) PVC tubing 3) Spacers 4) Insulators for transistors. E. When replacing AC primary side components (transformers, power cord, etc.), wrap ends of wires securely about the terminals before soldering. F. Observe that the wires do not contact heat producing parts (heat sinks, oxide metal film resistors, fusible resistors, etc.) G. Check that replaced wires do not contact sharp edged or pointed parts. H. When a power cord has been replaced, check that 11~13 lb (5~6 kg) of force in any direction will not loosen it. I. Also check areas surrounding repaired locations. J. Use care that foreign objects (screws, solder droplets, etc.) do not remain inside the set. K. When connecting or disconnecting the internal connectors, first, disconnect the AC plug from the AC supply outlet. L. When installing parts or assembling the cabinet parts, be sure to use the proper screws and tighten certainly. 2-3 LTVN_ISP Safety Check after Servicing Examine the area surrounding the repaired location for damage or deterioration. Observe that screws, parts and wires have been returned to original positions. Afterwards, perform the following tests and confirm the specified values in order to verify compliance with safety standards. 1. Clearance Distance When replacing primary circuit components, confirm specified clearance distance (d) and (d') between soldered terminals, and between terminals and surrounding metallic parts. (See Fig. 1) Chassis or Secondary Conductor Primary Circuit Table 1: Ratings for selected area AC Line Voltage Region Clearance Distance (d), (d’) 110 to 130 V U.S.A. or Canada ≥ 3.2 mm (0.126 inches) d' d Note: This table is unofficial and for reference only. Be sure to confirm the precise values. Fig. 1 2. Leakage Current Test Confirm the specified (or lower) leakage current between B (earth ground, power cord plug prongs) and externally exposed accessible parts (RF terminals, antenna terminals, video and audio input and output terminals, microphone jacks, earphone jacks, etc.) is lower than or equal to the specified value in the table below. Exposed Accessible Part Z AC Voltmeter (High Impedance) Measuring Method: (Power ON) Insert load Z between B (earth ground, power cord plug prongs) and exposed accessible parts. Use an AC voltmeter to measure across both terminals of load Z. See Fig. 2 and following table. B Earth Ground Power Cord Plug Prongs Fig. 2 Table 2: Leakage current ratings for selected areas AC Line Voltage Region Load Z Leakage Current (i) Earth Ground (B) to: 110 to 130 V U.S.A. or Canada 0.15 µF CAP. & 1.5 kΩ RES. Connected in parallel i ≤ 0.5 mA rms Exposed accessible parts Note: This table is unofficial and for reference only. Be sure to confirm the precise values. 2-4 LTVN_ISP STANDARD NOTES FOR SERVICING Circuit Board Indications How to Remove / Install Flat Pack-IC 1. The output pin of the 3 pin Regulator ICs is indicated as shown. 1. Removal With Hot-Air Flat Pack-IC Desoldering Machine: Top View Out 1. Prepare the hot-air flat pack-IC desoldering machine, then apply hot air to the Flat Pack-IC (about 5 to 6 seconds). (Fig. S-1-1) Bottom View In Input 2. For other ICs, pin 1 and every fifth pin are indicated as shown. 5 Pin 1 10 3. The 1st pin of every male connector is indicated as shown. Fig. S-1-1 2. Remove the flat pack-IC with tweezers while applying the hot air. Pin 1 3. Bottom of the flat pack-IC is fixed with glue to the CBA; when removing entire flat pack-IC, first apply soldering iron to center of the flat pack-IC and heat up. Then remove (glue will be melted). (Fig. S-1-6) Pb (Lead) Free Solder 4. Release the flat pack-IC from the CBA using tweezers. (Fig. S-1-6) Pb free mark will be found on PCBs which use Pb free solder. (Refer to figure.) For PCBs with Pb free mark, be sure to use Pb free solder. For PCBs without Pb free mark, use standard solder. CAUTION: 1. The Flat Pack-IC shape may differ by models. Use an appropriate hot-air flat pack-IC desoldering machine, whose shape matches that of the Flat Pack-IC. 2. Do not supply hot air to the chip parts around the flat pack-IC for over 6 seconds because damage to the chip parts may occur. Put masking tape around the flat pack-IC to protect other parts from damage. (Fig. S-1-2) Pb free mark 3-1 TVN_SN With Soldering Iron: 3. The flat pack-IC on the CBA is affixed with glue, so be careful not to break or damage the foil of each pin or the solder lands under the IC when removing it. CBA 1. Using desoldering braid, remove the solder from all pins of the flat pack-IC. When you use solder flux which is applied to all pins of the flat pack-IC, you can remove it easily. (Fig. S-1-3) Hot-air Flat Pack-IC Desoldering Machine Flat Pack-IC Desoldering Braid Soldering Iron Masking Tape Tweezers Flat Pack-IC Fig. S-1-3 2. Lift each lead of the flat pack-IC upward one by one, using a sharp pin or wire to which solder will not adhere (iron wire). When heating the pins, use a fine tip soldering iron or a hot air desoldering machine. (Fig. S-1-4) Fig. S-1-2 Sharp Pin Fine Tip Soldering Iron Fig. S-1-4 3. Bottom of the flat pack-IC is fixed with glue to the CBA; when removing entire flat pack-IC, first apply soldering iron to center of the flat pack-IC and heat up. Then remove (glue will be melted). (Fig. S-1-6) 4. Release the flat pack-IC from the CBA using tweezers. (Fig. S-1-6) 3-2 TVN_SN With Iron Wire: 2. Installation 1. Using desoldering braid, remove the solder from all pins of the flat pack-IC. When you use solder flux which is applied to all pins of the flat pack-IC, you can remove it easily. (Fig. S-1-3) 1. Using desoldering braid, remove the solder from the foil of each pin of the flat pack-IC on the CBA so you can install a replacement flat pack-IC more easily. 2. Affix the wire to a workbench or solid mounting point, as shown in Fig. S-1-5. 2. The “ I ” mark on the flat pack-IC indicates pin 1. (See Fig. S-1-7.) Be sure this mark matches the pin 1 on the PCB when positioning for installation. Then presolder the four corners of the flat pack-IC. (See Fig. S-1-8.) 3. While heating the pins using a fine tip soldering iron or hot air blower, pull up the wire as the solder melts so as to lift the IC leads from the CBA contact pads as shown in Fig. S-1-5. 3. Solder all pins of the flat pack-IC. Be sure that none of the pins have solder bridges. 4. Bottom of the flat pack-IC is fixed with glue to the CBA; when removing entire flat pack-IC, first apply soldering iron to center of the flat pack-IC and heat up. Then remove (glue will be melted). (Fig. S-1-6) Example : 5. Release the flat pack-IC from the CBA using tweezers. (Fig. S-1-6) Note: When using a soldering iron, care must be taken to ensure that the flat pack-IC is not being held by glue. When the flat pack-IC is removed from the CBA, handle it gently because it may be damaged if force is applied. Pin 1 of the Flat Pack-IC is indicated by a " " mark. Hot Air Blower or Fig. S-1-7 Presolder Iron Wire Soldering Iron To Solid Mounting Point Fig. S-1-5 Flat Pack-IC CBA CBA Fig. S-1-8 Fine Tip Soldering Iron Flat Pack-IC Tweezers Fig. S-1-6 3-3 TVN_SN Instructions for Handling Semiconductors Electrostatic breakdown of the semi-conductors may occur due to a potential difference caused by electrostatic charge during unpacking or repair work. 1. Ground for Human Body Be sure to wear a grounding band (1 MΩ) that is properly grounded to remove any static electricity that may be charged on the body. 2. Ground for Workbench Be sure to place a conductive sheet or copper plate with proper grounding (1 MΩ) on the workbench or other surface, where the semi-conductors are to be placed. Because the static electricity charge on clothing will not escape through the body grounding band, be careful to avoid contacting semi-conductors with your clothing. <Incorrect> CBA <Correct> Grounding Band 1MΩ CBA 1MΩ Conductive Sheet or Copper Plate 3-4 TVN_SN CABINET DISASSEMBLY INSTRUCTIONS [TYPE A] 1. Disassembly Flowchart Step/ Loc. No. This flowchart indicates the disassembly steps for the cabinet parts and the CBA in order to gain access to items to be serviced. When reassembling, follow the steps in reverse order. Bend, route and dress the cables as they were. [1] Stand Assembly [3] Digital Main CBA Unit [2] Rear Cabinet [7] Speaker [4] Main CBA [5] Stand Holder [8] IR Sensor CBA Unit [9] Function CBA Unit Removal [1] Stand Assembly D1 3(S-1) [2] Rear Cabinet D1 [3] 4(S-6), CN3005, Digital Main D2 CN3101, CN3102, CBA Unit D3 CN3701, CN3801, CN3802, Jack Holder 6(S-2), (S-3), (S-4), 2(S-5), 7(L-1) [9] Function CBA Unit D2 Function Knob D3 --- [10] Front Cabinet D2 --------------- --- ↓ (1) ↓ (2) ↓ (3) ↓ (5) ↓ (4) (3) Fig. No. showing procedure of part location (4) Identification of parts to be removed, unhooked, unlocked, released, unplugged, unclamped, or desoldered. P = Spring, L = Locking Tab, S = Screw, H = Hex Screw, CN = Connector e.g. 2(S-2) = two Screws of (S-2), 2(L-2) = two Locking Tabs of (L-2) (5) Refer to the following "Reference Notes in the Table." Note ----- --- [4] Main CBA 6(S-7), CN201, D2 CN601, CN1001, D3 CN1002, Guard Holder [5] Stand Holder D2 2(S-8), (S-9) --- [6] LCD Module Assembly D2 2(S-10) --- [7] Speaker D2 [8] IR Sensor CBA Unit D2 Sensor Lens, D3 Sensor Plate 3(S-11), Speaker Holder Note (2) Parts to be removed or installed. 2. Disassembly Method Fig. No. Removal (1) Order of steps in procedure. When reassembling, follow the steps in reverse order. These numbers are also used as the Identification (location) No. of parts in figures. [10] Front Cabinet Part Fig. No. Note: [6] LCD Module Assembly Step/ Loc. No. Part --- ----- 4-1 FL11.0-A_DC [2] Rear Cabinet (L-1) (S-2) (L-1) (L-1) (S-3) (S-4) (S-5) (S-2) (S-2) [1] Stand Assembly (S-1) Fig. D1 4-2 FL11.0-A_DC [10] Front Cabinet [3] Digital Main CBA Unit Jack Holder [9] Function CBA Unit (S-6) (S-6) Function Knob [7] Speaker (S-6) (S-10) (S-10) (S-11) Sensor Plate (S-11) Speaker Holder Sensor Lens (S-7) [8] IR Sensor CBA Unit (S-7) [6] LCD Module Assembly (S-8) (S-7) [5] Stand Holder (S-9) [4] Main CBA Guard Holder (S-7) Fig. D2 4-3 FL11.0-A_DC TV Cable Wiring Diagram To LCD Module Assembly To LCD Module Assembly Main CBA Digital Main CBA Unit CN201 CN3005 CN1001 CN301 CN3701 CN1002 CN3102 CN3101 CN601 CN3802 CN3801 To AC Cord IR Sensor CBA Unit To Speaker Function CBA Unit CN4002 CN4052 Fig. D3 4-4 FL11.0-A_DC [TYPE B] 1. Disassembly Flowchart Step/ Loc. No. This flowchart indicates the disassembly steps for the cabinet parts and the CBA in order to gain access to items to be serviced. When reassembling, follow the steps in reverse order. Bend, route and dress the cables as they were. [1] Stand Assembly [3] Digital Main CBA Unit [2] Rear Cabinet [8] Speaker [5] Main CBA [6] Stand Holder [4] Jack CBA [9] Function CBA Removal Function CBA D2 2(S-15) D3 --- [10] Front Cabinet D2 --------------- --- ↓ (1) ↓ (2) ↓ (3) ↓ (5) ↓ (4) (4) Identification of parts to be removed, unhooked, unlocked, released, unplugged, unclamped, or desoldered. P = Spring, L = Locking Tab, S = Screw, H = Hex Screw, CN = Connector e.g. 2(S-2) = two Screws of (S-2), 2(L-2) = two Locking Tabs of (L-2) (5) Refer to the following "Reference Notes in the Table." Note Stand Assembly D1 3(S-1) [2] Rear Cabinet D1 [3] 4(S-6), 2(S-7), 4(S-8), 2(H-1), CN301, Digital Main D2 CN302, CN3005, CBA Unit D3 Shield Box, Jack Holder(D) --- [4] Jack CBA 4(S-9), (S-10), CN702, D2 CN871, D3 Jack Holder(A) --- [5] Main CBA 10(S-11), CN102, D2 CN201, CN872, D3 CN1001, CN1002 --- [6] Stand Holder D2 2(S-12), (S-13) --- [7] LCD Module Assembly D2 --------------- --- [8] Speaker D2 4(S-14), Speaker Holder [9] (3) Fig. No. showing procedure of part location [1] 9(S-2), (S-3), (S-4), 2(S-5) Note (2) Parts to be removed or installed. 2. Disassembly Method Fig. No. Removal (1) Order of steps in procedure. When reassembling, follow the steps in reverse order. These numbers are also used as the Identification (location) No. of parts in figures. [10] Front Cabinet Part Fig. No. Note: [7] LCD Module Assembly Step/ Loc. No. Part ----- --- 4-5 FL11.0-B_DC [2] Rear Cabinet (S-2) (S-3) (S-2) (S-2) (S-4) (S-2) (S-5) (S-2) [1] Stand Assembly (S-1) Fig. D1 4-6 FL11.0-B_DC [3] Digital Main CBA Unit [10] Front Cabinet (S-8) Jack Holder(D) (S-7) Shield Box (S-8) (S-6) [7] LCD Module Assembly (S-7) [9] Function CBA [4] Jack CBA (S-10) (S-6) (H-1) Jack Holder(A) (S-9) (S-15) (S-11) [8] Speaker (S-14) (S-12) (S-14) (S-11) Speaker Holder Speaker Holder (S-13) [6] Stand Holder (S-11) (S-11) [5] Main CBA Fig. D2 4-7 FL11.0-B_DC TV Cable Wiring Diagram To LCD Module Assembly To LCD Module Assembly To LCD Module Assembly Digital Main CBA Unit Main CBA CN3005 CN201 CN1001 CN301 CN3002 CN302 CN3006 CN702 CN701 CN1002 CN102 CN872 AC Cord CN871 Jack CBA To Speaker Function CBA To Speaker CN101B Fig. D3 4-8 FL11.0-B_DC [TYPE C] 1. Disassembly Flowchart Step/ Loc. No. This flowchart indicates the disassembly steps for the cabinet parts and the CBA in order to gain access to items to be serviced. When reassembling, follow the steps in reverse order. Bend, route and dress the cables as they were. [1] Stand Assembly Part Fig. No. Removal [10] Front Cabinet D2 Module Spacer, Sensor Shield ↓ (1) ↓ (2) ↓ (3) Note ↓ (4) --↓ (5) Note: [3] Digital Main CBA Unit [2] Rear Cabinet [7] IR Sensor CBA Unit [5] Speaker [4] Main CBA [8] Function CBA Unit (1) Order of steps in procedure. When reassembling, follow the steps in reverse order. These numbers are also used as the Identification (location) No. of parts in figures. (2) Parts to be removed or installed. (3) Fig. No. showing procedure of part location [6] LED CBA Unit (4) Identification of parts to be removed, unhooked, unlocked, released, unplugged, unclamped, or desoldered. P = Spring, L = Locking Tab, S = Screw, H = Hex Screw, CN = Connector e.g. 2(S-2) = two Screws of (S-2), 2(L-2) = two Locking Tabs of (L-2) [9] LCD Module Assembly [10] Front Cabinet 2. Disassembly Method Step/ Loc. No. Part Fig. No. Removal (5) Refer to the following "Reference Notes in the Table." Note [1] Stand Assembly D1 2(S-1) --- [2] Rear Cabinet D1 3(S-2), 2(S-3), 15(L-1) --- [3] 4(S-4), CN3006, Digital Main D2 CN3102, CN3103, CBA Unit D3 CN3701, CN3801, CN3802, Jack Holder [4] Main CBA 7(S-5), CN603, D2 CN1001, D3 Stand Bracket --- [5] Speaker D2 --------------- --- [6] LED CBA Unit D2 LED Lens D3 --- [7] IR Sensor CBA Unit D2 CN4051, Sensor Lens D3 --- [8] Function CBA Unit D2 --------------D3 --- [9] LCD Module Assembly D2 --------------- --- --- 4-9 FL11.0-C_DC [2] Rear Cabinet (L-1) (L-1) (S-3) (L-1) (L-1) (S-2) [1] Stand Assembly (S-1) Fig. D1 4-10 FL11.0-C_DC [10] Front Cabinet [3] Digital Main CBA Unit Jack Holder Module Spacer (S-4) Module Spacer (S-4) Sensor Shield Sensor Lens [7] IR Sensor CBA Unit [9] LCD Module Assembly (S-5) LED Lens (S-5) [6] LED CBA Unit [8] Function CBA Unit [5] Speaker [4] Main CBA (S-5) (S-5) Stand Bracket Fig. D2 4-11 FL11.0-C_DC TV Cable Wiring Diagram To LCD Module Assembly To LCD Module Assembly Digital Main CBA Unit Main CBA CN3006 CN1001 Function CBA Unit CN601 CN3701 CN603 CN3102 CN3103 CN3802 CN3801 CN4002 To AC Cord IR Sensor CBA Unit CN4051 LED CBA Unit CN4052 To Speaker CN4101 Fig. D3 4-12 FL11.0-C_DC ELECTRICAL ADJUSTMENT INSTRUCTIONS How to set up the service mode: General Note: “CBA” is abbreviation for “Circuit Board Assembly.” Service mode: Note: Electrical adjustments are required after replacing circuit components and certain mechanical parts. It is important to perform these adjustments only after all repairs and replacements have been completed. Also, do not attempt these adjustments unless the proper equipment is available. 1. Turn the power on. 2. Press [MENU] button to display Setup menu. 3. Select “Features”. 4. Select “Current Software Info”. 5. Press [0], [4], [2], [5], [7], [4] and [INFO] buttons on the remote control unit in this order. The following screen appears. Test Equipment Required 1. Remote control unit "*" differs depending on the models. 2. Color Analyzer, CA-310 (KONICA MINOLTA Luminance meter) or measuring instrument as good as CA-310. Code: Pic code: Panel-Option code: MIPS: *******-**-**-****-** **********-***-*-** **-***-***-***-*** Push 0 key Press "POWER" key to exit. Tuner: ****-*****-**** Safety: Safety_Non HDMI EDID: ** PC EDID: ** 5-1 Total Watch Time: ***** Lightsensor: **** LC9EA 1. Purity Check Mode 2. VCOM Adjustment This mode cycles through full-screen displays of red, green, blue, and white to check for non-active pixels. Test Point Adj. Point 1. Enter the Service mode. Screen 2. Each time the [7] button on the remote control unit is pressed, the display changes as follows. [CHANNEL UP/DOWN] buttons M. EQ. Spec. Color analyzer See below Purity Check Mode Figure White mode To avoid interference from ambient light, this adjustment should be performed in a dark room. [7] button Perpendicularity [7] button Black mode Color Analyzer [7] button Red mode 1. Operate the unit for more than 60 minutes. 2. Set the color analyzer at the zero point calibration and bring the optical receptor pointing at the center of the LCD-Panel. Note: The optical receptor must be set perpendicularly to the LCD Panel surface. [7] button Green mode 3. Enter the Service mode. 4. Press [3] button on the remote control unit. 5. Press [CHANNEL UP/DOWN] buttons on the remote control unit so that the color analyzer value becomes minimum. [7] button 6. To cancel or to exit from the VCOM Adjustment, press [CH RETURN] or [PREV CH] button. Blue mode [7] button White 20% mode Note: When entering this mode, the default setting is White mode. 3. To cancel or to exit from the Purity Check Mode, press [CH RETURN] or [PREV CH] button. 5-2 LC9EA The White Balance Adjustment should be performed when replacing the LCD Panel or Digital Main CBA. 6. Press [MENU] button. The internal Raster signal appears on the screen. (“Internal (Single)” appears on the upper right of the screen as shown below.) 3. White Balance Adjustment Purpose: To mix red and blue beams correctly for pure white. Internal (Single) Symptom of Misadjustment: White becomes bluish or reddish. ITEM SPECIFICATION Color temperature x= 0.272 ± 0.002 y= 0.278 ± 0.002 Input Signal Internal pattern (40/70% raster) HDB 0 7. Press [CHANNEL UP/DOWN] buttons to adjust the color temperature becomes 12000°K (x= 0.272 / y= 0.278 ±0.002). Measurement point Screen center M. EQ. CA-310 (KONICA MINOLTA Luminance meter) or measuring instrument as good as CA-310. 8. Press [1] button to select the “HDR” for High Drive Red adjustment (“HDR” appears on the screen.) and press [CHANNEL UP/DOWN] buttons to adjust the color temperature. Aging time 60min. (Retail MODE/100IRE Raster HDMI 1080i@60) 9. If necessary, adjust the “HDB” or “HDR” again. MODE setting of TV Shipment setting/ Retail MODE Ambient temperature 25°C ± 5°C 10. Press [6] button to select the “LDB” for Low Drive Blue adjustment (“LDB” appears on the screen.) and press [CHANNEL UP/DOWN] buttons to adjust the color temperature. Internal (Single) 1. Operate the unit for more than 60 minutes. 2. Enter the Service mode. 3. Press [VOLUME DOWN] button three times on the remote control unit to select “Drive setting” mode. “Drive” appears on the screen. LDB 4. Set the color analyzer at the CHROMA mode and zero point calibration. Bring the optical receptor pointing at the center of the LCD-Panel. 0 11. Press [4] button to select the “LDR” for Low Drive Red adjustment (“LDR” appears on the screen.) and press [CHANNEL UP/DOWN] buttons to adjust the color temperature. To avoid interference from ambient light, this adjustment should be performed in a dark room. Perpendicularity 12. If necessary, adjust the “LDB” or “LDR” again. 13. Press [VOLUME DOWN] button to shift to the “Debugging Message” mode. If there is no message under “[WB]” section, this adjustment completes. If “Drive settings are NG. Retry.” is displayed, repeat above steps from 5. to 12. Then check “Debugging Message” again. If “Drive settings are NG. Retry.” is displayed, replace the LCD Panel or Digital Main CBA. Color Analyzer Note: The optical receptor must be set perpendicularly to the LCD Panel surface. 14. To cancel or to exit from the White Balance Adjustment, press [CH RETURN] or [PREV CH] button. 5. Press [3] button to select the “HDB” for High Drive Blue adjustment. (“HDB” appears on the screen.) 5-3 LC9EA HOW TO INITIALIZE THE LCD TV The purpose of initialization is to place the set in a new out of box condition. The customer will be prompted to select a language and program channels after the set has been initialized. To put the program back at the factory-default, initialize the LCD TV using the following procedure. 1. Turn the power on. 2. Enter the service mode. - To cancel the service mode, press [POWER] button on the remote control unit. 3. Press [FREEZE] button on the remote control unit to initialize the LCD television. 4. "INITIALIZED" will appear in the upper right of the screen. "INITIALIZED" color will change to green from red when initializing is completed. 6-1 LC9_INT FIRMWARE RENEWAL MODE Equipment Required TYPE C (Example: 19ME601B/F7) a. USB storage device b. Remote Control Unit Rear Cabinet USB port Firmware Update Procedure Note: There are two states (the User Upgrade and the Factory Upgrade) in firmware update. User Upgrade USB storage device Upgrade the firmware only. The setting values are not initialized. Factory Upgrade Upgrade the firmware and (Firmware upgrade) initialize the setting values. Factory Upgrade (Flash upgrade) Upgrade the firmware and initialize the setting values along with the setting data adjusted at the factory such as White Balance, etc. 3. Plug the AC cord in the wall outlet and turn the power on. 4. The update will start and the following will appear on the screen. The identification of User Upgrade and Factory Upgrade are done by the filename. "*" differs depending on the models. 1. Turn the power off and unplug the AC Cord. Software Upgrade 2. Insert the USB storage device to the USB port as shown below. Software upgrade in progress. Please wait. Do not remove the USB storage device or turn the TV off while upgrade is in progress. TYPE A (Example: 19MF301B/F7) Current Version: *******-***-*-***-**** New Version: *******-***-*-***-**** Rear Cabinet *1 Downloading... USB port 0% Note: If the above screen isn’t displayed, repeat from step 1. USB storage device The appearance shown in *1 is described as follows. Appearance State Downloading... Downloading the firmware from the USB storage device. Writing... Writing the downloaded firmware in flash memory. Checking... Checking the new firmware. TYPE B (Example: LC190SS2) USB port USB storage device Rear Cabinet 7-1 FL11.0FW 5. When the firmware update is completed, the following will appear on the screen. Software Upgrade The software upgrade is completed. Remove USB storage device, turn TV off then on again. Remove the USB storage device from the USB port. Turn the power off and turn the power on again. Note: When the Factory Upgrade is used, after restarting TV, shift to initial screen menu in service mode. "INITIALIZED" will appear on the upper right of the screen. "INITIALIZED" color will change to green from red when initializing is completed. 7-2 FL11.0FW TROUBLESHOOTING [TYPE A] [Power Supply Section] FLOW CHART NO.1 The power cannot be turned on. No Is the fuse (F601) normal? See FLOW CHART No.2 <The fuse blows out.> Yes Is normal state restored when once unplugged power cord is plugged again after several seconds? No Yes Is the P-ON+24V line voltage normal? Check if there is any leak or short-circuiting on the primary circuit component, and service it if defective. (D601, D602, D603, D604, Q601, Q602, T631) No Yes Check each rectifying circuit of the secondary circuit and service it if defective. FLOW CHART NO.2 The fuse blows out. Check the presence that the primary component is leaking or shorted and service it if defective. Check the presence that the rectifying diode or circuit is shorted in each rectifying circuit of secondary side, and service it if defective. After servicing, replace the fuse. FLOW CHART NO.3 When the output voltage fluctuates. Does the photocoupler circuit on the secondary side operate normally? No Check IC601, D633, Q631 and their periphery circuit, and service it if defective. Yes Check IC601, D608, D609 and their periphery circuit, and service it if defective. FLOW CHART NO.4 When buzz sound can be heard in the vicinity of power circuit. Check if there is any short-circuit on the rectifying diode and the circuit in each rectifying circuit of the secondary side, and service it if defective. (IC202, IC631, Q206, Q211, Q634, D631, D632, D636, D639, D670) 8-1 FL11.0ATR FLOW CHART NO.5 P-ON+24V is not output. Is approximately +24V voltage supplied to the cathode of D632? No Check C632, D632, D633 and their periphery circuit, and service it if defective. Yes Check if there is any leak or short-circuit on the loaded circuit, and service it if defective. FLOW CHART NO.6 PANEL+24V is not output. Is approximately +24V voltage supplied to the emitter of Q211? No See FLOW CHART No.5 <P-ON+24V is not output.> Yes Check Q211, Q212, P-ON-H1 line and their periphery circuit, and service it if defective. FLOW CHART NO.7 PANEL+13V is not output. Is approximately +17V voltage supplied to Pin(1) of IC202? No Check C631, D631, D668 and their periphery circuit, and service it if defective. Yes Is approximately +4V voltage supplied to Pin(2) of IC202? No Check Q202, Q203, D201, P-ON-H1 line and their periphery circuit, and service it if defective. Yes Replace IC202. FLOW CHART NO.8 +11V(AMP+11V) is not output. Is approximately +11V voltage supplied to the cathode of D670? No Check C695, D670, D671, D672 and their periphery circuit, and service it if defective. Yes Check if there is any leak or short-circuit on the loaded circuit, and service it if defective. 8-2 FL11.0ATR FLOW CHART NO.9 AL+5V is not output. Is approximately +6.5V voltage supplied to the cathode of D639? No Check C639, D639, D655, D657 and their periphery circuit, and service it if defective. Yes Check if there is any leak or short-circuit on the loaded circuit, and service it if defective. FLOW CHART NO.10 P-ON+3.3V is not output. Is approximately +6.5V voltage supplied to Pin(1) of IC631? No Check C639, D639 and their periphery circuit, and service it if defective. Yes Is approximately +5.6V supplied to Pin(2) of IC631? No Check Q638, Q639, P-ON-H2 line and their periphery circuit, and service it if defective. Yes Replace IC631. FLOW CHART NO.11 PANEL-7.1V is not output. Is approximately -12V voltage supplied to the anode of D636? No Check C636, D636 and their periphery circuit, and service it if defective. Yes Is approximately -11V voltage supplied to the base of Q206? No Check Q202, Q203, D204, P-ON-H1 line and their periphery circuit, and service it if defective. Yes Replace Q206. 8-3 FL11.0ATR [Video Signal Section] FLOW CHART NO.1 The key operation is not functioning. When pressing each switches (SW4001~SW4007) do the voltage of Pin(3) of CN4002 decrease? No Replace the Function CBA Unit. Yes Replace Digital Main CBA Unit. FLOW CHART NO.2 No operation is possible from the remote control unit. Operation is possible from the unit. Is approximately +3.3V voltage supplied to Pin(3) terminal of the remote control receiver (RS4051)? Yes Is the "L" pulse sent out Pin(1) terminal of remote control receiver (RS4051) when the infrared remote control is activated? Yes Is the "L" pulse supplied to Pin(2) of CN4052? No No No Check AL+3.3V line and service it if defective. Replace the IR Sensor CBA Unit or the remote control unit. Replace the IR Sensor CBA Unit. Yes Replace Digital Main CBA Unit. FLOW CHART NO.3 Picture does not appear normally. Is approximately +5.7V voltage supplied to Pin(11) of CN301? No See FLOW CHART NO.9 <AL+5V is not output. [Power Supply Section]> Yes Is approximately +11V voltage supplied to Pin(13, 14) of CN301? Yes Is approximately +24V voltage supplied to Pin(16, 17) of CN301? Yes No No See FLOW CHART NO.8 <+11V(AMP+11V) is not output. [Power Supply Section]> See FLOW CHART NO.5 <P-ON+24V is not output. [Power Supply Section]> CL3005, Digital Main CBA Unit or LCD Module Assembly may be defective. Check and replace these parts. 8-4 FL11.0ATR [Audio Signal Section] FLOW CHART NO.1 Audio is not outputted normally. Is approximately +5.7V voltage supplied to Pin(11) of CN301? No See FLOW CHART NO.9 <AL+5V is not output. [Power Supply Section]> Yes Is approximately +11V voltage supplied to Pin(13, 14) of CN301? Yes Is approximately +24V voltage supplied to Pin(16, 17) of CN301? Yes No No See FLOW CHART NO.8 <+11V(AMP+11V) is not output. [Power Supply Section]> See FLOW CHART NO.5 <P-ON+24V is not output. [Power Supply Section]> SP861, SP862, CL3801 or CL3802 may be defective. Check and replace these parts. 8-5 FL11.0ATR [TYPE B] [Power Supply Section] FLOW CHART NO.1 The power cannot be turned on. No Is the fuse (F601) normal? See FLOW CHART No.2 <The fuse blows out.> Yes Is normal state restored when once unplugged power cord is plugged again after several seconds? No Yes Is the INV+31V line voltage normal? Check if there is any leak or short-circuiting on the primary circuit component, and service it if defective. (D601, D602, D603, D604, Q601, Q602, T601) No Yes Check each rectifying circuit of the secondary circuit and service it if defective. FLOW CHART NO.2 The fuse blows out. Check the presence that the rectifying diode or circuit is shorted in each rectifying circuit of secondary side, and service it if defective. Check the presence that the primary component is leaking or shorted and service it if defective. After servicing, replace the fuse. FLOW CHART NO.3 When the output voltage fluctuates. Does the photocoupler circuit on the secondary side operate normally? No Check IC601, D633, Q631 and their periphery circuit, and service it if defective. Yes Check IC601, D608, D610 and their periphery circuit, and service it if defective. FLOW CHART NO.4 When buzz sound can be heard in the vicinity of power circuit. Check if there is any short-circuit on the rectifying diode and the circuit in each rectifying circuit of the secondary side, and service it if defective. (IC631, Q201, Q205, Q206, Q634, Q635, Q636, Q637, Q640, Q641, Q643, D631, D632, D636, D638, D639, D641, D643) FLOW CHART NO.5 INV+31V is not output. Is approximately +31V voltage supplied to the cathode of D632? No Check C632, D632, D633 and their periphery circuit, and service it if defective. Yes Check if there is any leak or short-circuit on the loaded circuit, and service it if defective. 8-6 FL11.0BTR FLOW CHART NO.6 PANEL+24.5V is not output. Is approximately +30V voltage supplied to the collector of Q205? No See FLOW CHART No.5 <INV+31V is not output.> Yes Check Q202, Q203, D203, P-ON-H1 line and their periphery circuit, and service it if defective. FLOW CHART NO.7 PANEL+13V is not output. Is approximately +15V voltage supplied to the collector of Q201? No Check C631, D631, D668 and their periphery circuit, and service it if defective. Yes Is approximately +13V voltage supplied to the base of Q201? No Check Q202, Q203, D201, D202, D210 and their periphery circuit, and service it if defective. Yes Replace Q201. FLOW CHART NO.8 P-ON+7V is not output. Is approximately +7V voltage supplied to the cathode of D641? No Check C641, D641 and their periphery circuit, and service it if defective. Yes Check if there is any leak or short-circuit on the loaded circuit, and service it if defective. FLOW CHART NO.9 P-ON+5V is not output. (PANEL+13V is outputted normally.) Is approximately +6.8V voltage supplied to the collector of Q635? No See FLOW CHART No.8 <P-ON+7V is not output.> Yes Is approximately +6V voltage supplied to the base of Q635 and the base of Q636? No Check D659 and their periphery circuit, and service it if defective. Yes Replace Q635 and Q636. 8-7 FL11.0BTR FLOW CHART NO.10 TUNER+5V is not output. (PANEL+13V is outputted normally.) Is approximately +6.7V voltage supplied to the collector of Q637? No See FLOW CHART No.8 <P-ON+7V is not output.> Yes Is approximately +6V voltage supplied to the base of Q637? No Check D659 and their periphery circuit, and service it if defective. Yes Replace Q637. FLOW CHART NO.11 P-ON+3V is not output. Is approximately +3V voltage supplied to the cathode of D638? No Check C638, D638 and their periphery circuit, and service it if defective. Yes Check if there is any leak or short-circuit on the loaded circuit, and service it if defective. FLOW CHART NO.12 P-ON+3.3V(PANEL+3.3V) is not output. Is approximately +5V voltage supplied to the cathode of D639? No Check C639, D639 and their periphery circuit, and service it if defective. Yes Is the "H" signal (approximately +3.5V) inputted to the base of Q640? No Check Q638, Q639, P-ON-H2 line and their periphery circuit, and service it if defective. Yes Replace Q640. FLOW CHART NO.13 P-ON+9V is not output. (PANEL+13V is outputted normally.) Is approximately +13V voltage supplied to the collector of Q641? No Check C643, D643 and their periphery circuit, and service it if defective. Yes Is approximately +10V voltage supplied to the base of Q641? No Check D666 and their periphery circuit, and service it if defective. Yes Replace Q641. 8-8 FL11.0BTR FLOW CHART NO.14 AL+3.3V is not output. Is approximately +34V voltage supplied to the collector of Q634? No See FLOW CHART No.5 <INV+31V is not output.> Yes Is approximately +5V voltage supplied to Pin(1) of IC631? No Check Q634, D650 and their periphery circuit, and service it if defective. Yes Replace IC631. FLOW CHART NO.15 LCD-7.1V is not output. Is approximately -9V voltage supplied to the anode of D636? No Check C636, D636, D637 and their periphery circuit, and service it if defective. Yes Is approximately -8V voltage supplied to the base of Q206? No Check Q202, Q203, D204, P-ON-H1 line and their periphery circuit, and service it if defective. Yes Replace Q206. 8-9 FL11.0BTR [Video Signal Section] FLOW CHART NO.1 The key operation is not functioning. Are the contact point and installation state of the key switches (SW104~SW109) normal? No Re-install the switches (SW104~SW109) correctly or replace the poor switch. Yes When pressing each switches (SW104~SW109) do the voltage of Pin(29) of CN302 decrease? No Check the switches (SW104~SW109) and their periphery, and service it if defective. Yes Replace Digital Main CBA Unit. FLOW CHART NO.2 No operation is possible from the remote control unit. Operation is possible from the unit. Is 3.3V voltage supplied to Pin(2) terminal of the remote control receiver (RS101)? No Check AL+3.3V line and service it if defective. Yes No Is the "L" pulse sent out Pin(1) terminal of remote control receiver (RS101) when the infrared remote control is activated? Replace the remote control receiver(RS101) or the remote control unit. Yes Is the "L" pulse supplied to Pin(25) of CN301? No Yes Check the line between Pin(1) terminal of remote control receiver(RS101) and Pin(25) of CN301, and service it if defective. Replace Digital Main CBA Unit. FLOW CHART NO.3 Picture does not appear normally.(Video input) Are the video signal inputted to Pin(4) of CN302? No Yes Check the line between Pin(4) of CN302 and JK752, and service it if defective. Replace Digital Main CBA Unit or LCD Module Assembly. 8-10 FL11.0BTR FLOW CHART NO.4 Picture does not appear normally.(Tuner input) Are the DIF signal inputted to Pin(26,28) of CN302? No Yes Check the line between Pin(26, 28) of CN302 and Pin(10, 11) of TU302, and service it if defective. Replace Digital Main CBA Unit or LCD Module Assembly. FLOW CHART NO.5 Picture does not appear normally.(S-Video input) Are the video signal outputted to Pin(6, 8) of CN302? No Pin(6): S-VIDEO-C Pin(8): S-VIDEO-Y Check the line between Pin(6, 8) of CN302 and JK751, and service it if defective. Yes Replace Digital Main CBA Unit or LCD Module Assembly. FLOW CHART NO.6 Picture does not appear normally.(Y/Pb/Pr input) Are the video signal inputted to Pin(15, 17, 19) of CN302? No Pin(15): VIDEO-Y Pin(17): VIDEO-Pb Pin(19): VIDEO-Pr Check the line between Pin(15, 17, 19) of CN302 and input terminals(JK731, JK732, JK733), and service it if defective. Yes Replace Digital Main CBA Unit or LCD Module Assembly. 8-11 FL11.0BTR [Audio Signal Section] FLOW CHART NO.1 Audio is not outputted normally.(Audio input) Are the audio(L/R) signals inputted to Pin(2, 15) of IC771? No Check the line between Pin(2, 15) of IC771 and input terminal(JK753, JK754), and service it if defective. Yes No Are the audio(L/R) signals inputted to Pin(6, 8) of CN301? Yes Replace Digital Main CBA Unit. Check the line between Pin(6, 8) of CN301 and Pin(3, 5) of IC803, and service it if defective. Are the audio(L/R) signals inputted to Pin(3, 5) of IC803? Yes No Are the audio(L/R) signals outputted to Pin(1, 7) of IC803? Yes No Are the audio(L/R) signals inputted to Pin(1, 9) of IC801? Yes No Check the line between Pin(1, 7) of IC803 and Pin(1, 9) of IC801, and service it if defective. Are the audio(L/R) signals outputted to Pin(4, 6) of IC801? No Check IC801 and their periphery circuit, and service it if defective. Replace IC803 Yes Check SP861,SP862 and their periphery circuit, and service it if defective. FLOW CHART NO.2 Audio is not outputted normally.(Component Audio input) Are the audio(L/R) signals inputted to Pin(4, 11) of IC771? No Check the line between Pin(4, 11) of IC771 and input terminal(JK741, JK742), and service it if defective. Yes Are the audio(L/R) signals inputted to Pin(6, 8) of CN301? Yes No Replace Digital Main CBA Unit. Check the line between Pin(6, 8) of CN301 and Pin(3, 5) of IC803, and service it if defective. Are the audio(L/R) signals inputted to Pin(3, 5) of IC803? Yes No Are the audio(L/R) signals outputted to Pin(1, 7) of IC803? Yes No Are the audio(L/R) signals inputted to Pin(1, 9) of IC801? Yes No Check the line between Pin(1, 7) of IC803 and Pin(1, 9) of IC801, and service it if defective. Are the audio(L/R) signals outputted to Pin(4, 6) of IC801? No Check IC801 and their periphery circuit, and service it if defective. Replace IC803 Yes Check SP861,SP862 and their periphery circuit, and service it if defective. 8-12 FL11.0BTR FLOW CHART NO.3 Audio is not outputted normally.(Tuner input) Are the DIF signals outputted to Pin(26, 28) of CN302? No Yes Are the audio(L/R) signals inputted to Pin(6, 8) of CN301? Yes No Check TU302 and their periphery circuit, and service it if defective. Replace Digital Main CBA Unit. Check the line between Pin(6, 8) of CN301 and Pin(3, 5) of IC803, and service it if defective. Are the audio(L/R) signals inputted to Pin(3, 5) of IC803? Yes No Are the audio(L/R) signals outputted to Pin(1, 7) of IC803? Yes No Are the audio(L/R) signals inputted to Pin(1, 9) of IC801? Yes No Check the line between Pin(1, 7) of IC803 and Pin(1, 9) of IC801, and service it if defective. Are the audio(L/R) signals outputted to Pin(4, 6) of IC801? No Check IC801 and their periphery circuit, and service it if defective. Replace IC803 Yes Check SP861,SP862 and their periphery circuit, and service it if defective. FLOW CHART NO.4 Audio is not outputted normally.(HDMI Audio input) Are the audio(L/R) signals inputted to Pin(5, 14) of IC771? No Check the line between Pin(5, 14) of IC771 and input terminal(JK721, JK722), and service it if defective. Yes Are the audio(L/R) signals inputted to Pin(6, 8) of CN301? Yes No Replace Digital Main CBA Unit. Check the line between Pin(6, 8) of CN301 and Pin(3, 5) of IC803, and service it if defective. Are the audio(L/R) signals inputted to Pin(3, 5) of IC803? Yes No Are the audio(L/R) signals outputted to Pin(1, 7) of IC803? Yes No Are the audio(L/R) signals inputted to Pin(1, 9) of IC801? Yes No Check the line between Pin(1, 7) of IC803 and Pin(1, 9) of IC801, and service it if defective. Are the audio(L/R) signals outputted to Pin(4, 6) of IC801? No Check IC801 and their periphery circuit, and service it if defective. Replace IC803 Yes Check SP861,SP862 and their periphery circuit, and service it if defective. 8-13 FL11.0BTR FLOW CHART NO.5 Audio is not outputted normally.(PC Audio input) Are the audio(L/R) signals inputted to Pin(1, 12) of IC771? No Check the line between Pin(1, 12) of IC771 and input terminal(JK711), and service it if defective. Yes Are the audio(L/R) signals inputted to Pin(6, 8) of CN301? Yes No Replace Digital Main CBA Unit. Check the line between Pin(6, 8) of CN301 and Pin(3, 5) of IC803, and service it if defective. Are the audio(L/R) signals inputted to Pin(3, 5) of IC803? Yes No Are the audio(L/R) signals outputted to Pin(1, 7) of IC803? Yes No Are the audio(L/R) signals inputted to Pin(1, 9) of IC801? Yes No Check the line between Pin(1, 7) of IC803 and Pin(1, 9) of IC801, and service it if defective. Are the audio(L/R) signals outputted to Pin(4, 6) of IC801? No Check IC801 and their periphery circuit, and service it if defective. Replace IC803 Yes Check SP861,SP862 and their periphery circuit, and service it if defective. 8-14 FL11.0BTR [TYPE C] [Power Supply Section] FLOW CHART NO.1 The power cannot be turned on. No Is the fuse (F601) normal? See FLOW CHART No.2 <The fuse blows out.> Yes Is normal state restored when once unplugged power cord is plugged again after several seconds? No Yes Is the P-ON+21V line voltage normal? Check if there is any leak or short-circuiting on the primary circuit component, and service it if defective. (D609, D610, D611, D612, Q607, Q608, T601) No Yes Check each rectifying circuit of the secondary circuit and service it if defective. FLOW CHART NO.2 The fuse blows out. Check the presence that the primary component is leaking or shorted and service it if defective. Check the presence that the rectifying diode or circuit is shorted in each rectifying circuit of secondary side, and service it if defective. After servicing, replace the fuse. FLOW CHART NO.3 When the output voltage fluctuates. Does the photocoupler circuit on the secondary side operate normally? No Check IC601, D620, D634, Q609 and their periphery circuit, and service it if defective. Yes Check IC601, D613, D614, D615, D616, D618 and their periphery circuit, and service it if defective. FLOW CHART NO.4 When buzz sound can be heard in the vicinity of power circuit. Check if there is any short-circuit on the rectifying diode and the circuit in each rectifying circuit of the secondary side, and service it if defective. (D619, D627, D629, Q611) 8-15 FL11.0CTR FLOW CHART NO.5 P-ON+21V is not output. Is approximately +21V voltage supplied to the cathode of D619? No Check C616, C632, C633, D619, D620 and their periphery circuit, and service it if defective. Yes Check if there is any leak or short-circuit on the loaded circuit, and service it if defective. FLOW CHART NO.6 AMP+11V is not output. Is approximately +12V voltage supplied to the cathode of D629? No Check C623, D629, D630, D661 and their periphery circuit, and service it if defective. Yes Check if there is any leak or short-circuit on the loaded circuit, and service it if defective. FLOW CHART NO.7 AL+5V is not output. Is approximately +6V voltage supplied to the cathode of D627? No Check C622, D627, D635, D636, D637, D640, D641, Q611 and their periphery circuit, and service it if defective. Yes Check if there is any leak or short-circuit on the loaded circuit, and service it if defective. 8-16 FL11.0CTR [Video Signal Section] FLOW CHART NO.1 The key operation is not functioning. When pressing each switches (SW4001~SW4007) do the voltage of Pin(6) of CN4052 decrease? No Replace the Function CBA Unit. Yes Replace Digital Main CBA Unit. FLOW CHART NO.2 No operation is possible from the remote control unit. Operation is possible from the unit. Is approximately +3.3V voltage supplied to Pin(3) terminal of the remote control receiver (RS4051)? Yes Is the "L" pulse sent out Pin(1) terminal of remote control receiver (RS4051) when the infrared remote control is activated? Yes Is the "L" pulse supplied to Pin(2) of CN4052? No No No Check AL+3.3V line and service it if defective. Replace the IR Sensor CBA Unit or the remote control unit. Replace the IR Sensor CBA Unit. Yes Replace Digital Main CBA Unit. FLOW CHART NO.3 Picture does not appear normally. Is approximately +5V voltage supplied to Pin(9) of CN601? No See FLOW CHART NO.7 <AL+5V is not output. [Power Supply Section]> Yes Is approximately +11V voltage supplied to Pin(6, 7) of CN601? Yes Is approximately +21V voltage supplied to Pin(3, 4) of CN601? Yes No No See FLOW CHART NO.6 <AMP+11V is not output. [Power Supply Section]> See FLOW CHART NO.5 <P-ON+21V is not output. [Power Supply Section]> CL3006, Digital Main CBA Unit or LCD Module Assembly may be defective. Check and replace these parts. 8-17 FL11.0CTR [Audio Signal Section] FLOW CHART NO.1 Audio is not outputted normally. Is approximately +5V voltage supplied to Pin(9) of CN601? No See FLOW CHART NO.7 <AL+5V is not output. [Power Supply Section]> Yes Is approximately +11V voltage supplied to Pin(6, 7) of CN601? Yes Is approximately +21V voltage supplied to Pin(3, 4) of CN601? Yes No No See FLOW CHART NO.6 <AMP+11V is not output. [Power Supply Section]> See FLOW CHART NO.5 <P-ON+21V is not output. [Power Supply Section]> SP3801, SP3802, CL3801 or CL3802 may be defective. Check and replace these parts. 8-18 FL11.0CTR 9-1 SCK SI SO CS T11 P11 R11 P12 H15 XIN25 H16 XOUT25 X3001 25MHz OSC SCK SIN SOUT CS P-ON-H1 C1 PROTECT1 C13 VCOM-PWM F2 P-ON-H2 B16 Q3005 TU3401 (TUNER UNIT) 4 SCL 3 SDA Q3006 AL+3.3V DIGITAL MAIN CBA UNIT SCL R12 SDA T12 PROTECT3 B13 BACKLIGHT-SW E2 BACKLIGHT-ADJ F3 G13 AUDIO-MUTE 6 5 2 1 AUDIO-MUTE IC3006 (MEMORY) TO VIDEO/AUDIO BLOCK DIAGRAM KEY-IN1 A15 REMOTE C14 LED1 J16 IC3005 (MAIN MICRO CONTROLLER) CN301 7 6 5 1 CN301 PROTECT3 4 BACKLIGHT-SW 2 BACKLIGHT-ADJ 3 P-ON-H2 P-ON-H1 PROTECT1 VCOM-PWM CN4052 2 5 CN3102 2 REMOTE 5 LED1 CN3701 7 6 5 1 CN3701 4 2 3 CN4002 3 CN3101 3 KEY-IN1 D4051 STANDBY MAIN CBA PROTECT3 BACKLIGHT-SW BACKLIGHT-ADJ P-ON-H2 P-ON-H1 PROTECT1 VCOM-PWM AL+3.3V TO INVERTER BLOCK DIAGRAM TO POWER SUPPLY BLOCK DIAGRAM IR SENSOR CBA UNIT REMOTE SENSOR RS4051 KEY SWITCH FUNCTION CBA UNIT [TYPE A] 1. System Control Block Diagram BLOCK DIAGRAMS FL11.0ABLS 3 9-2 SP862 SPEAKER R-CH SP861 SPEAKER L-CH JK3731 HEADPHONE JACK JK3702 DIGITAL AUDIO-OUT (COAXIAL) AUDIO(R)-IN AUDIO(L)-IN COMPONENT -Pr-IN JK3701 WF4 WF3 WF1 BUFFER BUFFER SP(R) GND SP(L) GND BUFFER GATE BUFFER GATE COMPONENT -Pb-IN JK3701 Q3011 Q3012 IC3014 IC3013 WF2 12 15 14 13 COMPONENT -Y/VIDEO-IN JK3001 PC-RGB IN 2 1 CN3802 1 2 CN3801 1 2 Q3701 BUFFER 6 4 MUTE CONTROL DRIVE DRIVE IC3801 (AUDIO AMP) 8 9 1 DIF-OUT1 6 DIF-OUT2 7 IF-AGC 5 TU3401 (TUNER UNIT) Q3805 DIGITAL MAIN CBA UNIT Q3801 AUDIO-MUTE AMP(L)-OUT AMP(R)-OUT SPDIF AUDIO(L) AUDIO(R) COM-VIDEO-Y/VIDEO-IN COM-VIDEO-Pb-IN COM-VIDEO-Pr-IN COMP-DET DIF-OUT1 DIF-OUT2 IF-AGC VGA-R-IN VGA-G-IN VGA-B-IN VGA-HSYNC VGA-VSYNC VGA-SCL VGA-SDA AUDIO SIGNAL TO SYSTEM CONTROL BLOCK DIAGRAM TO DIGITAL SIGNAL PROCESS BLOCK DIAGRAM VIDEO SIGNAL 2. Video/Audio Block Diagram FL11.0ABLVA 9-3 7 9 4 6 1 3 10 12 16 15 AUDIO(L) AUDIO(R) SPDIF AMP(L)-OUT AMP(R)-OUT IF-AGC COMP-DET DIF-OUT1 DIF-OUT2 DIGITAL MAIN CBA UNIT TMDS-D0(+) TMDS-D0(-) TMDS-D1(+) TMDS-D1(-) TMDS-D2(+) TMDS-D2(-) TMDS-CLOCK(+) TMDS-CLOCK(-) HDMI-DATA HDMI-CLOCK JK3004 HDMI-IN TO VIDEO/AUDIO BLOCK DIAGRAM C15 HDMI-SDA C16 HDMI-SCL Q3202 BUFFER B3 A3 B2 A2 B1 A1 B4 A4 A8 B8 N10 B7 A7 A/D CONVERTER VIDEO DECODER HDMI I/F AUDIO DECODER AUDIO I/F DEMODULATOR /MPEG DECODER SW VGA-SCL VGA-SDA VGA-HSYNC VGA-VSYNC A16 IF-AGC N12 COMP-DET A12 B12 C9 D8 B11 C10 C11 A9 C7 G14 F14 A14 B14 Q3201 BUFFER COM-VIDEO-Y/VIDEO-IN COM-VIDEO-Pb-IN COM-VIDEO-Pr-IN VGA-R-IN VGA-G-IN VGA-B-IN VGA-SCL VGA-SDA VGA-HSYNC VGA-VSYNC IC3005 (DIGITAL SIGNAL PROCESS) DIGITAL SIGNAL PROCESS LVDS TX TP POL CPV OE STV H1,H2,J1,J2,J4,K1, K3,L1,L2,M1-M3,N1 N4,N7,N8,P3,P4, P6-P8,R3,R4,R6, R8,T2-T5 P14 P13 N16 N15 P16 P15 T16 T15 R14 T14 R13 T13 R16 R15 L13 M15 L16 L15 M14 B1,B9,C2,C8, D1,D3,D7,D9, F1,F9,G2,G8, DATA(0-15) H1,H3,H7,H9 M2,M3,M7,M8, N2,N3,N7,N8, ADDRESS(0-12) P2,P3,P7,P8,R2 CN3005 23 22 21 20 19 18 13 12 11 10 9 8 16 15 6 5 4 3 1 AUDIO SIGNAL IC3002 (DDR2 SDRAM) VIDEO SIGNAL LLV0(+) LLV0(-) LLV1(+) LLV1(-) LLV2(+) LLV2(-) LLV3(+) LLV3(-) LLV4(+) LLV4(-) LLV5(+) LLV5(-) LLVCLK(+) LLVCLK(-) TP POL CPV OE1 STV LCD MODULE ASSEMBLY 3. Digital Signal Process Block Diagram FL11.0ABLD TO SYSTEM CONTROL BLOCK DIAGRAM +11V P-ON+24V 9-4 MAIN CBA PROTECT3 BACKLIGHT-SW BACKLIGHT-ADJ Q1002, Q1011 SW+11V Q1003 Q1023, Q1024 SW Q1019 2 1 15 16 3 4 DTC 14 V-REF 8 11 6 5 2 3 7 1 IC1002 (COMPARATOR) 5 6 OSC PWM CONTROL LOGIC IC1001(PWM CONTROL) 12 VCC Q1014 DRIVE Q1001, Q1007, Q1016 DRIVE Q1010, Q1017, Q1018 Q1004,Q1006, Q1008,Q1012 SW+11V CURRENT CONTROL SWITCH Q1005 T1002 1 3 2 4 OVER VOLTAGE PROTECTOR Q1015 OVER VOLTAGE PROTECTOR Q1009 6 5 8 7 CN1002 1 2 CN1001 1 2 LCD MODULE ASSEMBLY BACK LIGHT BACK LIGHT 4. Inverter Block Diagram FL11.0ABLINV AC601 AC CORD L601 F601 4A/125V LINE FILTER 9-5 Q602 SWITCHING CONTROL Q601 SWITCHING 4A/125V CN601 2 1 HOT CIRCUIT. BE CAREFUL. BRIDGE RECTIFIER D601- D604 FEED BACK Q631 COLD 2 3 HOT 1 12 11 10 9 8 7 4 IC601 5 6 1 2 3 T631 CAUTION ! Fixed voltage (or Auto voltage selectable) power supply circuit is used in this unit. If Main Fuse (F601) is blown , check to see that all components in the power supply circuit are not defective before you connect the AC plug to the AC power supply. Otherwise it may cause some components in the power supply circuit to fail. Q634 +5V REG. Q641 IC202 +13V REG. Q202,Q203 SWITCHING Q211, Q212 SW+24V 4A/125V Q633 Q206 SW-12V Q638,Q639 SWITCHING Q402 Q400 MAIN CBA IC631 +3.3V REG. PANEL-7.1V PANEL+13V PANEL+24V PANEL+3.3V VCOM DRIVE IC201,Q207, Q208,Q209 CN3701 16,17 13,14 11 P-ON-H1 P-ON-H2 PROTECT1 VCOM-PWM +11V P-ON+24V TO SYSTEM CONTROL BLOCKDIAGRAM DIGITAL MAIN CBA UNIT P-ON+24V AMP+11V AL+5V LCD MODULE ASSEMBLY NOTE: The voltage for parts in hot circuit is measured using hot GND as a common terminal. CN301 16,17 P-ON+24V 13,14 AMP+11V 11 AL+5V CN201 8 2,3 4 6,7 10 CAUTION ! : For continued protection against risk of fire, replace only with same type 4 A, 125V fuse. ATTENTION : Utiliser un fusible de rechange de même type de 4A, 125V. 5. Power Supply Block Diagram FL11.0ABLP 9-6 SCK SI SO CS DIGITAL MAIN CBA UNIT H15 XIN25 H16 XOUT25 X3001 25MHz OSC SCK SIN SOUT CS T11 P11 R11 P12 C13 D13 B13 F2 E2 F3 SCL R12 SDA T12 PROTECT1 PROTECT2 PROTECT3 VCOM-PWM BACKLIGHT-SW BACKLIGHT-ADJ G1 INPUT0 D1 INPUT1 G13 AUDIO-MUTE 6 5 2 1 INPUT0 INPUT1 AUDIO-MUTE IC3006 (MEMORY) TO AUDIO BLOCK DIAGRAM Q3005 PROTECT1 PROTECT2 PROTECT3 VCOM-PWM BACKLIGHT-SW BACKLIGHT-ADJ 22 SCL 21 SDA CN3005 11 15 5 29 26 28 CN3002 Q3006 CN302 22 21 CN301 11 15 5 29 26 28 CN301 25 27 9 13 1 REMOTE LED1 P-ON-H1 LED-R P-ON-H2 CN3002 25 27 9 13 1 REMOTE LED1 P-ON-H1 LED-R P-ON-H2 C14 J16 C1 F13 B16 CN302 29 CN3006 29 KEY-IN1 KEY-IN1 A15 IC3005 (MAIN MICRO CONTROLLER) Q172 DRIVE IC201,Q207, Q208,Q209 9 SCL 8 SDA * TU301 4 SCL 5 SDA * TU302 (TUNER UNIT) (TUNER UNIT) MAIN CBA Either TU301 or TU302 is used for Main CBA. Q171 CN102 2 5 4 6 PROTECT3 BACKLIGHT-SW BACKLIGHT-ADJ VCOM P-ON-H2 P-ON-H1 PROTECT1 PROTECT2 REMOTE P-ON-H1 LED1 KEY-IN1 KEY SWITCH D104 POWER AL+3.3V D103 STANDBY TO INVERTER BLOCK DIAGRAM TO POWER SUPPLY BLOCK DIAGRAM FUNCTION CBA CN101B 2 5 4 6 REMOTE SENSOR RS101 [TYPE B] 1. System Control Block Diagram FL11.0BBLS C 9-7 JACK CBA Y CN701 27 28 26 19 20 18 16 DIF-OUT1 12 DIF-OUT2 13 IF-AGC 14 (TUNER UNIT) * TU301 DIF-OUT1 11 DIF-OUT2 10 IF-AGC 9 (TUNER UNIT) * TU302 VIDEO-IN S-VIDEO-C-IN S-VIDEO-Y-IN S-VIDEO-SW-IN COM-VIDEO-Y-IN COM-VIDEO-Pb-IN COM-VIDEO-Pr-IN MAIN CBA Either TU301 or TU302 is used for Main CBA. JK731 COMPONENT -Y-IN JK732 COMPONENT -Pb-IN JK733 COMPONENT -Pr-IN JK751 S-VIDEO -IN JK752 VIDEO-IN CN702 27 28 26 19 20 18 16 WF4 WF2 WF5 WF3 WF6 WF1 JK3001 PC-RGB IN CN3006 4 6 8 5 15 17 19 CN3006 26 28 24 12 15 14 13 3 2 1 VIDEO-IN S-VIDEO-C-IN S-VIDEO-Y-IN S-VIDEO-SW COM-VIDEO-Y-IN COM-VIDEO-Pb-IN COM-VIDEO-Pr-IN CN302 26 DIF-OUT1 28 DIF-OUT2 24 IF-AGC CN302 4 6 8 5 15 17 19 IC3014 IC3013 BUFFER GATE BUFFER GATE DIF-OUT1 DIF-OUT2 IF-AGC VGA-SDA VGA-SCL VGA-VSYNC VGA-HSYNC VGA-B-IN VGA-G-IN VGA-R-IN VIDEO-IN S-VIDEO-C-IN S-VIDEO-Y-IN S-VIDEO-SW COM-VIDEO-Y-IN COM-VIDEO-Pb-IN COM-VIDEO-Pr-IN DIGITAL MAIN CBA UNIT AUDIO SIGNAL TO DIGITAL SIGNAL PROCESS BLOCK DIAGRAM VIDEO SIGNAL 2. Video Block Diagram FL11.0BBLV 9-8 SP862 SPEAKER R-CH SP861 SPEAKER L-CH JK851 HEADPHONE JACK JK841 DIGITAL AUDIO-OUT (COAXIAL) JK721 HDMIAUDIO(L)-IN JK722 HDMIAUDIO(R)-IN JK711 PC-AUDIO-IN JK741 COMPONENTAUDIO(L)-IN JK742 COMPONENTAUDIO(R)-IN JK753 AUDIO(L) -IN JK754 AUDIO(R) -IN SP(R) GND SP(L) GND BUFFER Q841 CN872 1 2 CN871 1 2 15 11 12 14 2 4 1 5 Q771 Q722 CN701 13 15 24 22 23 AUDIO(L) AUDIO(R) INPUT1 INPUT0 SPDIF MAIN CBA 8 9 DRIVE 6 MUTE CONTROL 1 DRIVE 4 IC801 (AUDIO AMP) Q773 BUFFER CN701 CN702 3,4 HEADPHONE(R) 3,4 9,10 HEADPHONE(L) 9,10 1,2 SP(R) 1,2 9 10 CONTROL LOGIC Q774 BUFFER 13 3 IC771 (AUDIO SELECTOR) JACK CBA 3 1 Q801 5 7 IC803 (OP AMP) CN702 13 15 24 22 23 WF7 CN3002 8 6 CN3006 2 20 CN302 2 SPDIF 20 AUDIO-MUTE CN3006 10 12 CN3006 13 11 CN301 8 AMP(R)-OUT 6 AMP(L)-OUT CN302 10 INPUT1 12 INPUT0 CN302 13 AUDIO(L) 11 AUDIO(R) DIGITAL MAIN CBA UNIT SPDIF AMP(R)-OUT AMP(L)-OUT INPUT1 INPUT0 AUDIO-MUTE AUDIO(L) AUDIO(R) TO DIGITAL SIGNAL PROCESS BLOCK DIAGRAM TO SYSTEM CONTROL BLOCK DIAGRAM TO DIGITAL SIGNAL PROCESS BLOCK DIAGRAM AUDIO SIGNAL 3. Audio Block Diagram FL11.0BBLA 9-9 TMDS-D0(+) TMDS-D0(-) TMDS-D1(+) TMDS-D1(-) TMDS-D2(+) TMDS-D2(-) TMDS-CLOCK(+) TMDS-CLOCK(-) HDMI-DATA HDMI-CLOCK 7 9 4 6 1 3 10 12 16 15 TO VIDEO BLOCK DIAGRAM IF-AGC S-VIDEO-SW DIF-OUT1 DIF-OUT2 2 3 15 14 10 11 AUDIO(L) AUDIO(R) SPDIF AMP(L)-OUT AMP(R)-OUT VGA-SCL VGA-SDA TMDS-D0(+) TMDS-D0(-) TMDS-D1(+) TMDS-D1(-) TMDS-D2(+) TMDS-D2(-) TMDS-CLOCK(+) TMDS-CLOCK(-) HDMI-DATA HDMI-CLOCK JK3004 HDMI-IN2 7 9 4 6 1 3 10 12 16 15 JK3003 HDMI-IN1 TO AUDIO BLOCK DIAGRAM TO VIDEO BLOCK DIAGRAM 57 56 60 59 63 62 54 53 51 52 42 41 45 44 48 47 39 38 36 37 SCL1 SDA1 SCL2 SDA2 SCL3 SDA3 SCL0 7 SDA0 6 HDMI SW 26 27 23 24 20 21 17 18 A8 B8 N10 B7 A7 VIDEO DECODER HDMI I/F G14 HDMI-SCL F14 HDMI-SDA B4 A4 B3 A3 B2 A2 B1 A1 AUDIO DECODER AUDIO I/F DEMODULATOR /MPEG DECODER SW A16 IF-AGC N12 S-VIDEO-SW A12 B12 C11 A9 C7 B9 C8 A10 C9 D8 B11 C10 A/D CONVERTER IC3005 (DIGITAL SIGNAL PROCESS) A14 HSYNC B14 VSYNC IC3018 (HDMI SW) IC3011 (EEPROM) VGA-R-IN VGA-G-IN VGA-B-IN VIDEO-IN S-VIDEO-C-IN S-VIDEO-Y-IN COM-VIDEO-Y-IN COM-VIDEO-Pb-IN COM-VIDEO-Pr-IN VGA-HSYNC VGA-VSYNC DIGITAL MAIN CBA UNIT DIGITAL SIGNAL PROCESS LVDS TX TP POL CPV OE STV H1,H2,J1,J2,J4,K1,K3, L1,L2,M1-M3,N1 N4,N7,N8,P3,P4,P6-P8, R3-R6,R8,T2-T5 P14 P13 N16 N15 P16 P15 T16 T15 R14 T14 R13 T13 R16 R15 L13 M15 L16 L15 M14 IC3002 (DDR2 SDRAM) CN3005 23 22 21 20 19 18 13 12 11 10 9 8 16 15 6 5 4 3 1 AUDIO SIGNAL B1,B9,C2,C8, D1,D3,D7,D9, F1,F9,G2,G8, DATA(0-15) H1,H3,H7,H9 M2,M3,M7,M8, N2,N3,N7,N8, ADDRESS(0-12) P2,P3,P7,P8,R2 VIDEO SIGNAL LLV0(+) LLV0(-) LLV1(+) LLV1(-) LLV2(+) LLV2(-) LLV3(+) LLV3(-) LLV4(+) LLV4(-) LLV5(+) LLV5(-) LLVCLK(+) LLVCLK(-) TP POL CPV OE1 STV LCD MODULE ASSEMBLY 4. Digital Signal Process Block Diagram FL11.0BBLD TO SYSTEM CONTROL BLOCK DIAGRAM 9-10 MAIN CBA PROTECT3 BACKLIGHT-SW BACKLIGHT-ADJ PANEL+15V INV+31V Q1002, Q1011 SW+16V Q1003 Q1023, Q1024 SW Q1019 2 1 15 16 3 4 DTC 14 VREF 8 11 6 5 2 3 7 1 IC1002 (COMPARATOR) 5 6 OSC PWM CONTROL LOGIC IC1001(PWM CONTROL) 12 VCC Q1014 DRIVE Q1001, Q1007, Q1016 DRIVE Q1010, Q1017, Q1018 Q1004,Q1006, Q1008,Q1012 SW+16V CURRENT CONTROL SWITCH Q1005 1 3 6 5 8 7 OVER VOLTAGE PROTECTOR Q1015 OVER VOLTAGE PROTECTOR Q1009 T1002 2 4 CN1002 1 2 CN1001 1 2 LCD MODULE ASSEMBLY BACK LIGHT BACK LIGHT 5. Inverter Block Diagram FL11.0BBLINV AC601 AC CORD LINE FILTER L601 9-11 BRIDGE RECTIFIER D601- D604 MAIN CBA Q602 SWITCHING CONTROL Q601 SWITCHING 4A/125V F601 4A/125V HOT CIRCUIT. BE CAREFUL. FEED BACK Q631 COLD 2 3 HOT 1 12 13 14 16 9 10 15 11 4 IC601 6 7 4 3 2 T601 CAUTION ! Fixed voltage (or Auto voltage selectable) power supply circuit is used in this unit. If Main Fuse (F601) is blown , check to see that all components in the power supply circuit are not defective before you connect the AC plug to the AC power supply. Otherwise it may cause some components in the power supply circuit to fail. Q633 Q632 SW+12.5V Q201,D202 SW+13V Q202,Q203 SWITCHING Q205 SW+24.5V 3 IC631 +3.3V REG. 2 Q637 SW+5V Q638,Q639 SWITCHING Q635,Q636 SW+5V Q640,D662 SW+3.3V Q641 SW+9V Q402 Q206 SW-7.1V CN301 10 16 21,22 19,20 14 CN201 8 2,3 4 6,7 10 CAUTION ! : For continued protection against risk of fire, replace only with same type 4 A, 125V fuse. ATTENTION : Utiliser un fusible de rechange de même type de 4A, 125V. Q634 +5V REG. 4A/125V P-ON+3V P-ON+7V AL+3.3V P-ON+3.3V P-ON+5V PANEL-7.1V PANEL+13V PANEL+24.5V P-ON+3.3V VCOM CN3002 10 16 21,22 19,20 14 P-ON-H1 P-ON-H2 PROTECT1 PROTECT2 VCOM TO SYSTEM CONTROL BLOCK DIAGRAM PANEL+15V PANEL+13V P-ON+3.3V P-ON+9V INV+31V P-ON+5V SP+14V TUNER+5V AL+3.3V DIGITAL MAIN CBA UNIT P-ON+3V P-ON+7V AL+3.3V P-ON+3.3V P-ON+5V LCD MODULE ASSEMBLY NOTE: The voltage for parts in hot circuit is measured using hot GND as a common terminal. 6. Power Supply Block Diagram FL11.0BBLP 9-12 SCK SI SO CS H15 XIN25 H16 XOUT25 X3001 25MHz OSC SCL R12 SDA T12 PROTECT3 B13 BACKLIGHT-SW E2 BACKLIGHT-ADJ F3 PROTECT1 C13 P-ON-H2 B16 DIGITAL MAIN CBA UNIT T11 P11 R11 P12 SCK SIN SOUT CS G13 AUDIO-MUTE 6 5 2 1 AUDIO-MUTE IC3006 (MEMORY) TO VIDEO/AUDIO BLOCK DIAGRAM KEY-IN1 A15 REMOTE C14 LED1 J16 IC3005 (MAIN MICRO CONTROLLER) Q3005 TU3401 (TUNER UNIT) 4 SCL 3 SDA Q3006 AL+3.3V P-ON+5V CN3701 4 PROTECT3 2 BACKLIGHT-SW 3 BACKLIGHT-ADJ CN3701 7 P-ON-H2 5 PROTECT1 CN3102 2 REMOTE 5 LED1 6 KEY-IN1 CN3103 1 P-ON+5V D4101 POWER CN601 16 18 17 CN601 13 15 MAIN CBA PROTECT3 BACKLIGHT-SW BACKLIGHT-ADJ KEY SWITCH TO LED BACKLIGHT DRIVE BLOCK DIAGRAM TO POWER SUPPLY BLOCK DIAGRAM FUNCTION CBA UNIT CN4002 3 P-ON-H2 PROTECT1 CN4051 3 KEY-IN1 AL+3.3V D4051 STANDBY IR SENSOR CBA UNIT CN4052 2 5 6 REMOTE SENSOR RS4051 LED CBA UNIT CN4101 1 [TYPE C] 1. System Control Block Diagram FL11.0CBLS 9-13 SP3802 SPEAKER R-CH SP3801 SPEAKER L-CH JK3731 HEADPHONE JACK JK3702 DIGITAL AUDIO-OUT (COAXIAL) AUDIO(R)-IN AUDIO(L)-IN COMPONENT -Pr-IN JK3701 WF4 WF3 WF1 BUFFER BUFFER SP(R) GND SP(L) GND BUFFER GATE BUFFER GATE COMPONENT -Pb-IN JK3701 Q3011 Q3012 IC3014 IC3013 WF2 12 15 14 13 3 2 COMPONENT -Y/VIDEO-IN JK3001 PC-RGB IN 1 CN3802 1 2 CN3801 1 2 Q3701 BUFFER 6 4 MUTE CONTROL DRIVE DRIVE IC3801 (AUDIO AMP) 8 9 1 DIF-OUT1 6 DIF-OUT2 7 IF-AGC 5 TU3401 (TUNER UNIT) Q3805 DIGITAL MAIN CBA UNIT Q3801 AUDIO-MUTE AMP(L)-OUT AMP(R)-OUT SPDIF AUDIO(L) AUDIO(R) COM-VIDEO-Y/VIDEO-IN COM-VIDEO-Pb-IN COM-VIDEO-Pr-IN COMP-DET DIF-OUT1 DIF-OUT2 IF-AGC VGA-R-IN VGA-G-IN VGA-B-IN VGA-HSYNC VGA-VSYNC VGA-SCL VGA-SDA AUDIO SIGNAL TO SYSTEM CONTROL BLOCK DIAGRAM TO DIGITAL SIGNAL PROCESS BLOCK DIAGRAM VIDEO SIGNAL 2. Video/Audio Block Diagram FL11.0CBLVA 9-14 7 9 4 6 1 3 10 12 16 15 AUDIO(L) AUDIO(R) SPDIF AMP(L)-OUT AMP(R)-OUT IF-AGC COMP-DET DIF-OUT1 DIF-OUT2 DIGITAL MAIN CBA UNIT TMDS-D0(+) TMDS-D0(-) TMDS-D1(+) TMDS-D1(-) TMDS-D2(+) TMDS-D2(-) TMDS-CLOCK(+) TMDS-CLOCK(-) HDMI-DATA HDMI-CLOCK JK3004 HDMI-IN TO VIDEO/AUDIO BLOCK DIAGRAM C15 HDMI-SDA C16 HDMI-SCL Q3202 BUFFER B3 A3 B2 A2 B1 A1 B4 A4 A8 B8 N10 B7 A7 A/D CONVERTER VIDEO DECODER HDMI I/F AUDIO DECODER AUDIO I/F DEMODULATOR /MPEG DECODER SW VGA-SCL VGA-SDA VGA-HSYNC VGA-VSYNC A16 IF-AGC N12 COMP-DET A12 B12 C9 D8 B11 C10 C11 A9 C7 G14 F14 A14 B14 Q3201 BUFFER COM-VIDEO-Y/VIDEO-IN COM-VIDEO-Pb-IN COM-VIDEO-Pr-IN VGA-R-IN VGA-G-IN VGA-B-IN VGA-SCL VGA-SDA VGA-HSYNC VGA-VSYNC IC3005 (DIGITAL SIGNAL PROCESS) DIGITAL SIGNAL PROCESS LVDS TX TP POL CPV OE STV H1,H2,J1,J2,J4,K1, K3,L1,L2,M1-M3,N1 N4,N7,N8,P3,P4, P6-P8,R3,R4,R6, R8,T2-T5 P14 P13 N16 N15 P16 P15 T16 T15 R14 T14 R13 T13 R16 R15 L13 M15 L16 L15 M14 B1,B9,C2,C8, D1,D3,D7,D9, F1,F9,G2,G8, DATA(0-15) H1,H3,H7,H9 M2,M3,M7,M8, N2,N3,N7,N8, ADDRESS(0-12) P2,P3,P7,P8,R2 CN3006 23 22 21 20 19 18 13 12 11 10 9 8 16 15 6 5 4 3 1 AUDIO SIGNAL IC3002 (DDR2 SDRAM) VIDEO SIGNAL LLV0(+) LLV0(-) LLV1(+) LLV1(-) LLV2(+) LLV2(-) LLV3(+) LLV3(-) LLV4(+) LLV4(-) LLV5(+) LLV5(-) LLVCLK(+) LLVCLK(-) TP POL CPV OE1 STV LCD MODULE ASSEMBLY 3. Digital Signal Process Block Diagram FL11.0CBLD TO SYSTEM CONTROL BLOCK DIAGRAM BACKLIGHT-SW BACKLIGHT-ADJ PROTECT3 P-ON+21V Q1001 9-15 CONTROL LOGIC MAIN CBA 14 13 1 16 10 OVP IC1001 (LED BACKLIGHT DRIVER) 4 5 DRIVE 3 DRIVE DRIVE 2 DRIVE CN1001 6 4 2 1 3 VLED ILED1 ILED2 ILED3 ILED4 LCD MODULE ASSEMBLY 4. LED Backlight Drive Block Diagram FL11.0CBLBD AC601 AC CORD L601 F601 4A/125V LINE FILTER 9-16 Q608 SWITCHING CONTROL Q607 SWITCHING 4A/125V CN603 2 1 HOT CIRCUIT. BE CAREFUL. BRIDGE RECTIFIER D609- D612 FEED BACK Q609 COLD 2 3 HOT 1 7 8 9 10 11 12 4 IC601 6 5 3 2 1 T601 CAUTION ! Fixed voltage (or Auto voltage selectable) power supply circuit is used in this unit. If Main Fuse (F601) is blown , check to see that all components in the power supply circuit are not defective before you connect the AC plug to the AC power supply. Otherwise it may cause some components in the power supply circuit to fail. Q610 4A/125V Q616 Q611 +5V REG. MAIN CBA Q631 P-ON+21V AMP+11V AL+5V TO SYSTEM CONTROL BLOCKDIAGRAM P-ON+21V DIGITAL MAIN CBA UNIT P-ON-H2 PROTECT1 CN3701 16,17 13,14 11 NOTE: The voltage for parts in hot circuit is measured using hot GND as a common terminal. CN601 3,4 P-ON+21V 6,7 AMP+11V 9 AL+5V CAUTION ! : For continued protection against risk of fire, replace only with same type 4 A, 125V fuse. ATTENTION : Utiliser un fusible de rechange de même type de 4A, 125V. 5. Power Supply Block Diagram FL11.0CBLP SCHEMATIC DIAGRAMS / CBA AND TEST POINTS Standard Notes WARNING Many electrical and mechanical parts in this chassis have special characteristics. These characteristics often pass unnoticed and the protection afforded by them cannot necessarily be obtained by using replacement components rated for higher voltage, wattage, etc. Replacement parts that have these special safety characteristics are identified in this manual and its supplements; electrical components having such features are identified by the mark “#” in the schematic diagram and the parts list. Before replacing any of these components, read the parts list in this manual carefully. The use of substitute replacement parts that do not have the same safety characteristics as specified in the parts list may create shock, fire, or other hazards. Notes: 1. Do not use the part number shown on these drawings for ordering. The correct part number is shown in the parts list, and may be slightly different or amended since these drawings were prepared. 2. All resistance values are indicated in ohms (K = 103, M = 106). 3. Resistor wattages are 1/4W or 1/6W unless otherwise specified. 4. All capacitance values are indicated in µF (P = 10-6 µF). 5. All voltages are DC voltages unless otherwise specified. 6. This schematic diagrams are masterized version that should cover the entire FL11.0 chassis models. Thus some parts in detail illustrated on this schematic diagrams may vary depend on the model within the FL11.0 chassis. Please refer to the parts lists for each models. 7. The Circuit Board layout illustrated on this service manual is the latest version for this chassis at the moment of making this service manual. Depend on the mass production date of each model, the actual layout of each Board may differ slightly from this version. 10-1 FL11.0SC LIST OF CAUTION, NOTES, AND SYMBOLS USED IN THE SCHEMATIC DIAGRAMS ON THE FOLLOWING PAGES: 1. CAUTION: CAUTION: FOR CONTINUED PROTECTION AGAINST RISK OF FIRE, REPLACE ONLY WITH SAME TYPE_A,_V FUSE. ATTENTION: UTILISER UN FUSIBLE DE RECHANGE DE MÊME TYPE DE_A,_V. 2. CAUTION: Fixed Voltage (or Auto voltage selectable) power supply circuit is used in this unit. If Main Fuse (F601) is blown, first check to see that all components in the power supply circuit are not defective before you connect the AC plug to the AC power supply. Otherwise it may cause some components in the power supply circuit to fail. 3. Note: 1. Do not use the part number shown on the drawings for ordering. The correct part number is shown in the parts list, and may be slightly different or amended since the drawings were prepared. 2. To maintain original function and reliability of repaired units, use only original replacement parts which are listed with their part numbers in the parts list section of the service manual. 4. Voltage indications on the schematics are as shown below: Plug the TV power cord into a standard AC outlet.: 2 1 (Unit: Volt) 3 5.0 Voltage 5.0 Power on mode Indicates that the voltage is not consistent here. 5. How to read converged lines 1-D3 Distinction Area Line Number (1 to 3 digits) 3 AREA D3 2 Examples: 1. "1-D3" means that line number "1" goes to the line number "1" of the area "D3". 1 2. "1-B1" means that line number "1" goes to the line number "1" of the area "B1". 1-B1 AREA B1 1-D3 A B C D 6. Test Point Information : Indicates a test point with a jumper wire across a hole in the PCB. : Used to indicate a test point with a component lead on foil side. : Used to indicate a test point with no test pin. : Used to indicate a test point with a test pin. The reference number of parts on Schematic Diagrams/CBA can be retrieved by application search function. 10-2 FL11.0SC Main 1 Schematic Diagram [TYPE A] CAUTION ! Fixed voltage (or Auto voltage selectable) power supply circuit is used in this unit. If Main Fuse (F601) is blown , check to see that all components in the power supply circuit are not defective before you connect the AC plug to the AC power supply. Otherwise it may cause some components in the power supply circuit to fail. 2 NOTE You cannot mix components under Type 1 with the ones under Type 2. Refer to Parts List of LC190EM2(Serial No.: TH1). CAUTION ! : For continued protection against risk of fire, replace only with same type 4 A, 125V fuse. ATTENTION : Utiliser un fusible de rechange de même type de 4A, 125V. 4A/125V Type 1 Type 2 IC202 KIA78R000ZF-RTF/P NOTE: The voltage for parts in hot circuit is measured using hot GND as a common terminal. 3 NOTE You cannot mix components under Type 1 with the ones under Type 2. Refer to Parts List of LC190EM2(Serial No.: TH1). Type 1 PQ200WNA1ZPH Type 2 R202 9.1k 8.2k IC631 KIA78R000ZF-RTF/P 1k R646 R203 510 680 R653 R204 1k 2.2k PQ200WNA1ZPH 2.2k 330 1.4k R403 47K D418 HOT CIRCUIT. BE CAREFUL. C402 OPEN T631 POWER TRANS SA601 SURGE ABSORBER 6 D604 1N5397BD 3 D601 1N5397BD D603 1N5397BD D602 1N5397BD R603 390K R604 390K 3 10 2 11 R662A OPEN R634 OPEN C607 560P /2KV Q601 TK5A50D (SWITCHING) G 5.2 0 S R606 330K D204 5.2 C633 1500P /1KV R609 1.5K D633 1ZB30BB R214 22K R213 27K 12 Q602 2SC2120-Y (SWITCHING) 2 D615 1ZB36BB R613 0.56/2W R610A OPEN R610 2.2K R212 10K 0 0.7 R244 22K R211 47K 0 R671 OPEN C691 OPEN C642 OPEN D637 OPEN C643 OPEN Q635 OPEN R672 OPEN R673 OPEN C202 *2R203 *2R202 OPEN 680 8.2K R674 OPEN C646 OPEN R611 220 23.3 R612 120 22.3 R636 10K C645 2200P R235 8.2K R235A OPEN C205 22/50V R239A OPEN R245 27K R246 47K C640 10/50V D655 D649 3V3BSB-T26 23.6 R651 10 R661A OPEN C635 OPEN 5.6 R661 220 R652A OPEN 1 2 4 3 D634 5V6BSB-T26 D648 5V6BSB-T26 Q641 2SC2412K (SWITCHING) HOT R638A OPEN 18.6 0 0 R633 47K COLD R641 1.1K R640 18K R656 220 *3 C638 R655 OPEN 240 R653 330 5.6 Q634 KTC3198 -Y-AT/P (+5V REG) R652 WIRE D674 OPEN D651 WIRE D673 OPEN C652 100/10V R699 OPEN R660 OPEN C637 0.1 R666 22K R632 WIRE R682 WIRE R632A OPEN R682A OPEN R650 220 R649 220 0 R413 22K R414 22K Q400 2SC2412K (RESET) -0.3 R670 4.7K Q638 2SC2412K (SWITCHING) 0.7 0 D650 5V6BSB-T26 0.7 6.3 5.6 Q639 2SA1576UBTLQ (SWITCHING) C641 0.1 R417 27K R635 47K R418 4.7K R668 47K R669 10K C661 3.3/50V D642 D404 D417 R677 0 C668 OPEN 3.3 0 D657 1ZB7.5BB C647 100/10V CONTINUE MAIN 2 P-ON+24V +11V PROTECT3 BACKLIGHT-ADJ BACKLIGHT-SW PROTECT1 R699A OPEN R660A OPEN R667 1K D416 10BSB-T26 R639 18K 0 Q633 2SC2412K (SWITCHING) 0 R206 OPEN D208 OPEN R656A R650A R649A OPEN OPEN OPEN D656 R638 3.9K C662 OPEN R240 OPEN C667 OPEN C666 OPEN *3 R646 2.2K C634 0.1 R651A OPEN R614 120 5.6 CONTINUE MAIN 2 PANEL-7.1V PANEL+3.3V PANEL+24V PANEL+13V VCOM-PWM D406 R210 6.8K D209 OPEN 0 R247 10K C204 4.7/50V 6.4 R643 27K R642 27K R209 56K R239 OPEN Q210 OPEN C656 OPEN 22.3 6.2 Q631 2SC2412K (FEED BACK) 1 D405 R416 2.7K D409 R612A R614A OPEN OPEN IC601 TLP781F ERROR VOLTAGE DET 0.5 R415 6.8K C208 0.1 R236 4.7K D640 OPEN D609 14.9 R241A OPEN R242A OPEN 1 2 3 4 5 6.4 5.6 3.3 1.3 0 R675 OPEN C606 1800P C201 470/25V R241 OPEN R242 OPEN *3 IC631 PQ200WNA1ZPH (+3.3V REG.) C644 OPEN R676 OPEN 23.6 Q211 2SA1037AK T146R (SW+24V) Q636 OPEN C605 0.082 R611A OPEN *2 R204 2.2K R205 22K 0 0.7 Q212 2SC2412K (SWITCHING) 0 JS632 OPEN D638 OPEN R609A OPEN D608 23.0 JS631 OPEN C693 OPEN C203 0.1 D201 23.6 C692 3300P/250V D605 4V3BSB-T26 Q402 2SC2412K (SWITCHING) 0 23.6 Q202 23.0 2SA1037AKT146R (SWITCHING) Q203 2SC2412K (SWITCHING) 0.5 0 C212 100/25V R208 OPEN R408 47K 1 2 3 4 5 17.24.1 13.31.3 0 R207A OPEN R608A R607A OPEN OPEN C604 0.039 R406 100K 23.7 BC601 BEAD R608 R607 150 150 D607 27BSB-T26 C602 1800P R201A OPEN R220 47K R634A OPEN R605 390K 167.8 D R243A OPEN R201 WIRE R207 OPEN C603 220/200V 1 C206 OPEN C207 10/50V R208A OPEN C632 1000/35V R602 1.2/3W D610 1ZB220-YBB D671 1ZB20BB R662 15K R222A OPEN C639 100/10V D632 SB3150BH 9 D668 1ZB22BB C695 470/25V D639 SK16-TR 8 5 L601 LINE FILTER C631 470/25V D670 SK2B-TR 7 -11.0 R223 15K 3.2 -0.7 C665 OPEN C664 OPEN C663 OPEN R601 2.7M/1/2W R221 22K R407 47K GND 4A 125V R401 1 D631 SK2B-TR R631 12K ADJ C601 0.47/300V F601 4A/125V C636 100/25V R243 180 GND D636 SK16-T/R *2 IC202 PQ200WNA1ZPH (+13V REG.) D207 7V5BSA-T26 Q206 2SC2412K R222 (SW-12V) 180 -11.8 -11.8 ADJ 0 VOUT CN601 1 2 Q401 2SC2412K (SWITCHING) VOUT C401 1/50V VC 7.1 -3.0 VIN AC601 AC CORD D402 R402 8V2BSB-T26 9.1K VIN D401 SK16-T/R VC 4 C685 0.1 R648 10K R647 47K MAIN CBA C669 OPEN D672 SK16-T/R CN301 1.3 1 3.3 2 0.4 3 3.2 4 3.2 5 3.3 6 3.3 7 3.4 8 0 9 0 10 5.7 11 0 12 10.9 13 10.9 14 0 15 23.7 16 23.7 17 0 18 0 19 TO DIGITAL MAIN CBA UNIT CN3701 VCOM-PWM BACKLIGHT-SW BACKLIGHT-ADJ PROTECT3 PROTECT1 P-ON-H1 P-ON-H2 RESET GND GND AL+5V GND AMP+11V AMP+11V GND P-ON+24V P-ON+24V GND GND UNLESS OTHERWISE SPECIFIED: DIODES ARE 1SS133. A B C D 10-3 E F G FL11.0SCMA1 Main 2 Schematic Diagram [TYPE A] MAIN CBA 4 Q1011 2SA950-Y (SW+11V) 11.1 11.1 R1031A OPEN C1020 0.1 R1074 100K Q1006 2SA1037AKT146R (SW+11V) 11.1 R1025 11.1 1.5K 10.4 C1011 1000 /35V D1016 1SS133 0.8 0.1 R1042 22K 0 0.1 0.7 R1048 22K 0 Q1008 2SC2412K SWITCHING BACKLIGHT-ON Q1012 2SC2412K SWITCHING BACKLIGHT-ON R1065 2.7K R1067 1K 3.4 Q1010 0.4 2SC2412K R1068 0 (DRIVE) 1K D1018 6V8BSB-T26 R1028 1K R1027 5.1K D1021 15BSB-T26 R1039 68K R1024 22K R1035 1K Q1001 2SC2412K (DRIVE) 11.0 3.3 C1050 OPEN BC1002 BEAD C1059 OPEN 2 4.9 0.9 C1016 6800P C1026 0.1 D1028 4V7BSB-T26 R1032 0.33/2W R1105 3.3K Q1023 2SC2412K (SWITCHING) 4.5 0.1 R1106 0 10K R1052 D1045 100K 1SS133 R1043 5.1K R1094 12K C1029 R1017A R1093A OPEN 0.01 OPEN /250V R1094A OPEN R1091 12K R1013 12K C1002 0.01 /250V C1023 R1013A R1091A OPEN 0.01 OPEN /250V R1092A OPEN R1081 100K C1031 1000P /100V R1053 OPEN R1046 C1028 24K 0.01 R1044 5.1K R1056 30K R1011 12K R1010A OPEN R1112 0 R1071 4.3K R1073 1.2K 1 R1011A OPEN D1022 1SS133 C1042 0.1 R1083 1M R1058 10K R226 10 C1056 0.1 5.4 5.6 Q207 2SC2655-Y (V-COM DRIVE) R228 WIRE 5.4 0 R229A OPEN J IC201 TL3472CDR (COMPARATOR) 5.6 Q208 KTA1281-Y-AT/P (V-COM DRIVE) LCD MODULE ASSEMBLY 0 R1014 27K D1004 1SS133 0 0 R1029 1.8K R1029A OPEN D1020 5V1BSB-T26 C1043 R1089 0.22 12K C210 OPEN C1041 0.01 CONTINUE MAIN 1 PANEL-7.1V PANEL+3.3V PANEL+24V PANEL+13V VCOM-PWM R233 10K C211 OPEN C221 OPEN R237 OPEN R231 1.5K C217 47/25V C220 OPEN R230 10K GND 1 2 3 4 0.2 0.2 0 0 C219 OPEN R232 15K 13.35.4 5.4 5.4 8 7 6 5 VCC C218 0.1 3.7 0 0.4 Q209 2SC2412K (V-COM DRIVE) R234 1K CN201 0 1 13.3 2 13.3 3 23.6 4 0 5 3.3 6 3.3 7 -7.1 8 0 9 5.4 10 0 11 TO LCD MODULE ASSEMBLY GND PANEL+13V PANEL+13V PANEL+24V GND PANEL+3.3V PANEL+3.3V PANEL-7.1V GND VCOM GND R229 10 K 10-4 C215 0.1 R224 1 C216 1 R1072 270 C1037 1 R1088 1M C209 47/25V R228A OPEN I R1087 68K R227 100K C214 1000P D1001 1SS133 D1025 1SS133 R226A OPEN C1044 0.1 BACK LIGHT C1039 0.01 11.20 2.8 1.1 8 7 6 5 VCC IC1002 KIA358F-EL (COMPARATOR) GND 1 2 3 4 0 2.8 1.1 0 D1029 12BSB-T26 D1030 12BSB-T26 R1012 27K 0.1 Q1015 2SC2412K OVER VOLTAGE PROTECTOR 0.7 C1032 R1060 10K 0.01 R1090 47K R225 0 13.3 D1038 WIRE C1045 0.1 H R1061 33K D1024 1SS133 R1086 100K R1059 10k Q1014 2SC2412K (SWITCHING) C1003 0.01 C1012 OPEN R1055 R1054 220K 13K 0 0 R1045 240K C1036 OPEN 3.6 R1022 33K C1009 10/50V 1 2 3 4 0.3 3.3 0.3 3.3 R1008 R1008A OPEN 12K 3.3 0 D1023 1SS133 R1082 68K R1010 10 0.2 0.3 5.0 5.0 11.12.2 0 0 16 15 14 13 12 11 10 9 V-REF CTL VCC DRIVE PWM CONTROL LOGIC DRIVE OSC DTC GND 1 2 3 4 5 6 7 8 1.9 2.5 1.0 0.6 1.6 3.6 0 2.2 Q1009 2SC2412K OVER VOLTAGE PROTECTOR 0.7 R1023 10K C1033 10/50V 23.123.123.123.1 8 7 6 5 R1007A OPEN Q1019 2SC2412K OVER VOLTAGE PROTECTOR 0 R1084 C1040 1000P 100K D1011 DAP202UT106 R1007 10 R1109 2.2K R1095 1.2K R1020 D1034 11BSB-T26 1K C1030 1000P R1093 12K R1047 OPEN C1015 10P /6.3KV CN1001 2 1 3.3 0 C1021 R1034 R1057 R1051 OPEN 33K 390K 390K R1009 1K D1010 DAP202UT106 C1005 R1017 0.01 12K /250V C1019 OPEN BACK LIGHT R1050 390K D1002 1SS133 R1036 15K R1040 6.2K IC1001 TL494CDR PWM CONTROL C1027 10/50V R1110 10K 5 R1030A OPEN C1053 100/16V R1041 1K 6 3 C1013 OPEN D1031 1SS133 R1019 390 Q1005 TPC8214-H CURRENT CONTROL SWITCH 5.0 Q1024 2SA1037AKT146R (SWITCHING) 1 C1010 10/50V CN1002 2 1 C1014 10P /6.3KV Q1003 2SC2412K OVER VOLTAGE PROTECTOR 0.1 C1004 R1016 0.01 10K R1015 D1005 6V2BSB-T26 10K R1018 390 D1009 DAN202UT106 D1003 1SS133 R1037 C1025 0.01 0 C1024 0.01 7 C1008 10P /6.3KV 3.3 Q1007 2SA1037AK 0 T146R (DRIVE) C1017 OPEN R1107 10K 8 4 D1036 1SS133 D1006 DAP202UT106 C1055 OPEN R1038 240K C1054 0.1 2 C1046 1000P C1001 1200P R1092 12K R1030 20K R1021 OPEN C1058 OPEN R1111 10K D1015 DAP202UT106 D1013 DAP202UT106 T1002 INVERTER TRANS C1048 OPEN 3.4 3.4 Q1016 0.4 2SC2412K 0 (DRIVE) BC1003 BEAD 3.3 3.4 Q1018 2SA1037AK 0 T146R (DRIVE) 3.4 R1069 1K Q1004 2SC2412K SWITCHING BACKLIGHT-ON 0 R1002 180 C1049 OPEN R1066A R1066 OPEN 2.7K C1035 0.01 0 R1049 12K C1034 0.01 R1070 1K C1038 0.1 0.8 D1017 1SS133 R1065A OPEN R1026A OPEN C1018 0.1 R1003 R1002A 2.2K OPEN R1006A Q1017 2SC2412K OPEN (DRIVE) 11.0 3.3 R1006 180 3.4 C1047 OPEN 0.1 0 R1026 2.2K BC1001 BEAD R1001A R1003A OPEN OPEN R1001 2.2K 0.7 R1005 22K CONTINUE MAIN 1 P-ON+24V +11V PROTECT3 BACKLIGHT-ADJ BACKLIGHT-SW PROTECT1 R1031 4.7K Q1002 2SC2412K SWITCHING BACKLIGHT-ON R1004 10K C1007 1200P R1099 10.4 1K C1022 100 /16V 3 C1006 10P/6.3KV L M FL11.0SCMA2 Main 1 Schematic Diagram [TYPE B] MAIN CBA 4 R1117 WIRE JS1010 OPEN JS1011 R1118 1.2 Q1020 OPEN R1034 OPEN R1033 OPEN Q1011 2SA950-Y (SW+16V) 15.9 16.9 31.431.531.431.4 8 7 6 5 R1099 15.2 1K C1020 0.1 C1023 10/50V C1052 0.1 R1031 4.7K D1019 OPEN D1031 Q1002 OPEN KTC3199-GR-AT/P SWITCHING 0.1 BACKLIGHT-ON R1004 10K R1001 2.2K Q1006 KTA1267-GR-AT/P (SW+16V) 15.8 15.9 R1067 1K R1066 2.7K C1035 0.01 R1069 1K R1025 1.5K 15.1 C1011 1000 /35V C1018 0.1 0 D1016 1SS133 R1039 68K 0.8 0 Q1008 KTC3199-GR-AT/P SWITCHING BACKLIGHT-ON R1100 WIRE R1049 12K 0.8 0.1 Q1012 KTC3199 R1042 0 -GR-AT/P 22K SWITCHING BACKLIGHT-ON 0.1 0.7 Q1004 KTC3199 R1048 0 -GR-AT/P 22K JS1004 SWITCHING OPEN BACKLIGHT-ON JS1005 2 R1035 1K R1021 OPEN D1033 OPEN C1054 0.1 D1003 1SS133 C1059 OPEN D1008 1SS133 D1007 1SS133 D1012 1SS133 D1027 D1036 1SS133 1SS133 R1018 D1026 390 1SS133 2 8 4 7 1 6 D1013 C1001 D1010 2200P 1SS133 1SS133 D1009 1SS133 3 5 C1008 10P/6KV D1028 4V7BSB-T26 R1032 0.33/2W C1024 0.01 R1093 12K R1094 12K R1092 12K R1013 12K C1002 0.022 /100V R1091 12K R1052 D1045 100K 1SS133 R1043 5.1K C1031 2700P /100V R1053 OPEN JS1007 R1109 2.2K R1046 C1028 24K 0.01 31.431.431.431.4 8 7 6 5 C1012 220P /500V D1022 1SS133 R1082 68K IC1002 KIA358F-EL (OP AMP) R1011 D1030 16BSB-T26 12K D1040 OPEN R1086 100K LCD MODULE ASSEMBLY R1014 27K D1004 1SS133 0 0 R1062 R1051 R1050 390K 390K 390K R1029 1.8K C1039 0.01 D1024 1SS133 R1087 68K 15.80 1.7 1.1 8 7 6 5 VCC D1020 5V1BSB-T26 C1043 R1089 0.22 12K GND 1 2 3 4 0.2 1.7 1.1 3.6 D1025 1SS133 R1088 1M C1041 0.01 R1059 10k 3.8 0.2 Q1014 KTC3199-GR-AT/P (SWITCHING) 0 R1112 0 R1064 33K R1090 47K 1 2 3 4 0.2 3.6 0.2 3.6 R1104 OPEN C1021 OPEN C1042 0.22 R1083 1M D1001 1SS133 0 C1033 10/50V D1037 1SS133 D1023 1SS133 R1012 27K 0.1 Q1015 KTC3199-GR-AT/P OVER VOLTAGE PROTECTOR 0.7 C1032 R1060 0.01 10K R1061 33K R1081 100K R1047 OPEN BACK LIGHT 0 R1056 R1057 R1055 R1054 5.6K 100k OPEN 51K R1045 240K D1041 OPEN Q1009 KTC3199-GR-AT/P OVER VOLTAGE PROTECTOR 0.7 R1023 10K C1003 0.01 C1009 10/50V R1009 1K C1015 10P /6KV CN1001 2 1 3.3 Q1019 KTC3199-GR-AT/P OVER VOLTAGE PROTECTOR 3.3 0 0 R1084 C1040 1000P 100K C1055 OPEN C1005 R1017 0.022 12K /100V BACK LIGHT D1011 1SS133 R1019 390 D1006 R1022 1SS133 33K C1036 OPEN 0.3 0.3 5.2 5.2 15.93.3 0 0 16 15 14 13 12 11 10 9 V-REF CTL VCC DRIVE PWM CONTROL LOGIC DRIVE OSC GND DTC 1 2 3 4 5 6 7 8 1.5 2.6 0.7 1.3 1.6 3.8 0 3.3 C1013 OPEN JS1012 R1103 OPEN R1036 15K R1040 6.2K R1015 D1005 6V2BSB-T26 10K C1010 10/50V CN1002 2 1 C1014 10P /6KV Q1003 KTC3199-GR-AT/P OVER VOLTAGE PROTECTOR 0.4 C1004 R1016 OPEN 0.01 R1020 D1034 9V1BSB-T26 1K R1008 D1029 12K 16BSB-T26 C1053 100/25V D1038 WIRE C1045 0.1 JS1013 OPEN R1102 OPEN D1039 OPEN D1015 1SS133 R1010 10 R1044 5.1K R1095 1.2K R1030 12K C1026 0.1 R1037 C1025 0 0.01 C1016 6800P R1108 WIRE 1 2 3 4 0.2 3.5 0.2 3.5 Q1022 OPEN CURRENT CONTROL SWITCH R1041 1K R1105 3.3K C1058 OPEN T1002 INVERTER TRANS D1014 1SS133 D1002 1SS133 R1038 240K IC1001 TL494CDR PWM CONTROL C1027 10/50V R1110 Q1023 10K KTC3199 -GR-AT/P (SWITCHING) 3.7 0.2 R1106 0 10K C1007 2200P C1019 220P /500V R1111 10K D1035 OPEN R1024 22K R1107 10K Q1024 5.2 KTA1267 4.9 -GR-AT/P (SWITCHING) 1.9 Q1017 KTC3199-GR-AT/P (DRIVE) R1101 OPEN 15.6 3.5 C1017 R1002 R1006 180 OPEN 3.7 C1047 180 R1007 OPEN 10 3.5 3.7 Q1018 Q1001 KTA1267-GR-AT/P KTC3199 0 (DRIVE) -GR-AT/P (DRIVE) 15.6 3.6 C1048 OPEN 3.7 3.6 3.7 Q1007 KTA1267-GR-AT/P 0 (DRIVE) C1050 OPEN D1018 10BSB-T26 R1028 1K R1027 5.1K C1038 D1021 0.1 15BSB-T26 R1026 2.2K Q1010 KTC3199 -GR-AT/P (SWITCHING) 3.7 Q1016 0.3 KTC3199 0 -GR-AT/P (SWITCHING) R1070 1K CONTINUE MAIN 4 INV+31V PANEL+15V CONTINUE MAIN 4 PROTECT3 BACKLIGHT-SW BACKLIGHT-ADJ C1049 OPEN 3.7 0.4 R1068 0 1K 0 R1065 2.7K R1074 100K R1003 2.2K C1034 0.01 0.7 R1005 24K 3 Q1005 TPC8214-H CURRENT CONTROL SWITCH R1096 OPEN R1097 OPEN C1006 10P/6KV R1058 10K C1044 0.1 C1056 0.1 R1113 OPEN JS1006 OPEN R1114 OPEN Q1025 OPEN (SWITCHING) 1 R1115 OPEN R1116 OPEN C1057 OPEN R1071 R1072 4.3K 0 R1073 1.2K A B C1037 1 C D 10-5 E F FL11.0SCMB1 Main 2 Schematic Diagram [TYPE B] *Either TU301 or TU302 is used for MAIN CBA. 4 CONTINUE MAIN 4 TU-VT+31V TUNER+5V P-ON+9V DVD-M+10V(EV+9V DVD+5V AL+3.3V P-ON+5V JS306 BC301 BK1608HS601-T 3 2 R914 OPEN C305 0.1 C301 0.1 C302 0.1 R917 OPEN 0.2 0.8 Q902 OPEN R916 0 (SWITCHING) OPEN R925 OPEN 4.6 3.4 R924 Q903 OPEN 4.0 OPEN (SW+3.3V) R922 OPEN C306 22/50V D303 5V6BSB-T26 C303 330/10V R923 OPEN C311 47P L303 LK1608R22KT C310 47P L302 LK1608R22KT R912 OPEN R913 OPEN C913 OPEN C915 OPEN R910 OPEN C916 OPEN C912 OPEN C911 OPEN R915 OPEN C309 1000P R307 R313 OPEN 0 R306 OPEN R305 56 D905 OPEN R929 OPEN 5.2 R928 OPEN 4.1 R927 OPEN R920 OPEN C914 OPEN C917 OPEN D907 OPEN 3.4 Q904 OPEN (SW+3.3V) R926 OPEN C918 OPEN D417 1SS133 R303 0 R302 0 D301 OPEN C314 OPEN D302 OPEN C315 OPEN C920 OPEN R909 OPEN D415 OPEN WF6 WF4 WF7 R224 1 WF3 R227 100K C214 1000P R226 10K WF1 13.3 5.8 6.0 Q207 2SC2655-Y (V-COM DRIVE) R228 WIRE 5.8 0 6.0 Q208 2SA1020-Y (V-COM DRIVE) R229 10K IC201 TL3472CDR (COMPARATOR) R907 OPEN 9.2 4.0 Q907 OPEN C906 4.6 (BUFFER) OPEN C215 0.1 C209 47/25V WF2 C908 OPEN 9.2 3.9 C929 Q906 OPEN OPEN 4.6 (BUFFER) R233 10K R225 0 SPDIF VIDEO-IN S-VIDEO-SW S-VIDEO-C-IN S-VIDEO-Y-IN INPUT1 AUDIO(R) INPUT0 AUDIO(L) COM-VIDEO-Y-IN COM-VIDEO-Pb-IN COM-VIDEO-Pr-IN AUDIO-MUTE C909 OPEN BC901 OPEN WF5 C210 OPEN C211 OPEN C212 OPEN C213 OPEN BC902 OPEN R237 OPEN R238 0 13.26.1 5.8 5.8 8 7 6 5 VCC C216 1 C217 47/25V C928 OPEN 5.2 0 R941 OPEN R905 OPEN C927 OPEN R230 10K R232 15K GND 1 2 3 4 0.2 0.2 0 0 R908 OPEN C907 OPEN R231 1.5K R904 OPEN R234 1K R940 OPEN 0.2 Q209 KTC3199-GR-AT/P (V-COM DRIVE) JS801 0 C925 OPEN IC902 OPEN (OP AMP) JS802 0 JS803 0 JS804 0 R931 OPEN R943 OPEN C905 L901 OPEN OPEN R942 OPEN 9.2 4.9 4.7 4.6 8 7 6 5 VCC JS805 OPEN C902 OPEN R902 OPEN GND 1 2 3 4 4.6 4.6 4.6 0 R903 OPEN R935 OPEN C903 OPEN C924 OPEN C926 OPEN C922 OPEN R936 OPEN C923 OPEN CONTINUE MAIN 3 KEY-IN1 KEY-IN2 DVD-LED PROTECT1 C901 OPEN R901 OPEN R933 OPEN CN901 3.4 1 3.3 2 3.4 3 1.3 4 1.3 5 3.4 6 3.4 7 3.4 8 3.4 9 5.2 10 9.6 11 9.6 12 0 13 0 14 0 15 0 16 0 17 0 18 0 19 20 21 22 23 24 25 26 (NO CONNECTION) AL+3.3V LED-CONT DVD-DISC-OUT EV+1.2V EV+1.2V EV+3.3V EV+3.3V EV+3.3V DVD-ON+3.3V DVD-ON+5V EV+9V EV+9V GND GND GND GND GND GND GND PWRCON(NU) DVD-SCLK DVD-CS DVD-DISC-IN DVD-SDATA DVD-REMOTE DVD-P-ON CN303 0 1 3.4 2 0.6 3 4 3.2 5 0 6 2.7 7 2.4 8 3.4 9 0 10 2.5 11 0 12 2.5 13 0 14 3.4 15 3.3 16 0 17 0.9 18 0 19 0.9 20 0 21 0.6 22 0 23 4.0 24 3.4 25 3.8 26 0 27 1.7 28 0 29 (NO CONNECTION) GND KEY-IN2 DVD-LED P-ON-H3(NU) DVD-MAIN-PWR DVD-P-ON DVD-REMOTE DVD-SDATA DVD-DISC-IN GND DVD-CS GND DVD-SCLK GND DVD-DISC-OUT LED-CONT GND DVD-Pr GND DVD-Pb GND DVD-Y GND DVD-AUDIO(L) DVD-AUDIO-MUTE DVD-AUDIO(R) GND DVD-SPDIF GND CN902 0.9 13 0 12 0.9 11 0 10 0.6 9 0 8 0 7 0 6 1.6 5 3.4 4 1.6 3 0 2 1.7 1 (NO CONNECTION) DVD-Pr GND DVD-Pb GND DVD-Y GND GND GND DVD-AUDIO(L) DVD-AUDIO-MUTE DVD-AUDIO(R) GND DVD-SPDIF 2.5 2.4 3.4 2.4 2.7 0 R921 OPEN D906 OPEN C919 OPEN R304 56 R919 OPEN R679 10K CONTINUE MAIN 3 1 5.2 4.5 JS301 OPEN JS303 OPEN C304 L301 0.1 BEAD TO DIGITAL MAIN CBA UNIT CN3006 CN302 KEY-IN1 29 3.4 DIF-OUT2 28 0.2 0 GND 27 DIF-OUT1 26 1.7 GND 25 0 IF-AGC 24 0 RESET 23 3.3 SCL 22 3.3 SDA 21 3.3 AUDIO-MUTE 20 0 COM-VIDEO-Pr-IN 19 0 GND 18 0 COM-VIDEO-Pb-IN 17 0 GND 16 0 COM-VIDEO-Y-IN 15 0 GND 14 0 AUDIO(L) 13 4.0 INPUT0 12 0 AUDIO(R) 11 4.0 INPUT1 10 0 GND 9 0 S-VIDEO-Y-IN 8 0 GND 7 0 S-VIDEO-C-IN 6 0 S-VIDEO-SW 5 3.3 VIDEO-IN 4 0 GND 3 0 SPDIF 2 1.7 GND 1 0 D904 OPEN JS305 JS304 R911 OPEN 1 2 3 0 1.3 3.9 Q901 OPEN (SWITCHING) 5.3 R918 OPEN VIN 1 2 3 4 5 6 7 8 9 10 11 VOUT 9 10 11 12 13 14 15 16 17 18 19 GND NU NU NU SCL SDA +32V +5V NU IF-AGC DIF-OUT2 DIF-OUT1 1 2 3 4 5 6 7 8 JS308 OPEN JS307 OPEN CONTINUE MAIN 4 VCOM-PWM VCOM RESET PANEL+13V IC901 OPEN (+1.2V REG.) TUNER UNIT SCL NU NU DIF-OUT1 DIF-OUT2 IF-AGC +5V NU NU NU NU *TU302 NU NU NU +5V NU +32V GND SDA *TU301 TUNER UNIT C904 OPEN MAIN CBA G H I J 10-6 K L FL11.0SCMB2 Main 3 Schematic Diagram [TYPE B] MAIN CBA CN862A 1 2 3 4 C801 OPEN 4 CONTINUE MAIN 4 LED1 REMOTE P-ON-H1-SW TO FUNCTION CBA CN101B GND REMOTE AL+3.3V LED1 P-ON-H1 KEY-IN1 KEY-IN2 DVD-LED 3 (NO CONNECTION) SP(R) SP(R) SP-GND SP-GND CN872 1 SP(R) 2 SP-GND SP862 SPEAKER R-CH CN102 1 2 3 4 5 6 7 8 CONTINUE MAIN 4 P-ON+5V P-ON+9V P-ON+3.3V AL+3.3V SP+14V JS103 OPEN JS101 OPEN C805 330/25V C807 0.022 R804 8.2 D808 20BSB-T26 R806 WIRE CONTINUE MAIN 2 KEY-IN1 KEY-IN2 DVD-LED PROTECT1 C802 0.1 BC801 BK1608HS601-T C806 330/25V R807 WIRE R815 470 R808 4.7K C812 470/25V C831 100/16V R816 470 R809 360 D804 1SS133 C811 0.1 CONTINUE MAIN 4 PROTECT1 AMP(R)-OUT AMP(L)-OUT R810 12K R836 100K R821 100K C827 1 C830 1000P 2 R834 10K D413 1SS133 R409 D414 2.2K 6V2BSB-T26 IC803 NJM4558M(TE1) (OP AMP) D805 1SS133 R818 15K C813 100/25V C825 1 R819 10K R820 4.7K R838 10K R837 100K C832 0.1 2.1 1 0 2 GND 7.0 3 RIPPLE FILTER 6.9 4 0 5 GND C816 820P R817 18K C828 390P 9.2 4.6 4.6 4.6 8 7 6 5 VCC R803 10K 7.0 6 14.4 7 VCC 13.0 8 R842 100K C833 0.1 D809 20BSB-T26 IC801 TDA1517P/N3 (AUDIO AMP) C809 1 R811 1.2K C808 0.022 R805 8.2 C838 OPEN DRIVE R678 OPEN NU 16 0 NU 15 0 NU 14 0 NU 13 0 NU 12 0 NU 11 0 MUTE CONTROL 2.1 9 NU 18 0 NU 17 0 DRIVE NU 10 0 C818 OPEN CONTINUE MAIN 2 SPDIF VIDEO-IN S-VIDEO-SW S-VIDEO-C-IN S-VIDEO-Y-IN INPUT1 AUDIO(R) INPUT0 AUDIO(L) COM-VIDEO-Y-IN COM-VIDEO-Pb-IN COM-VIDEO-Pr-IN AUDIO-MUTE C819 OPEN C820 OPEN C821 OPEN C829 1000P R830 10K R826 10K R823 100K C810 1 1 R813 1.2K M N R814 12K TO JACK CBA CN701 SP(R) SP(R) HEADPHONE(R) HEADPHONE(R) GND GND GND GND HEADPHONE(L) HEADPHONE(L) GND GND AUDIO(L) P-ON+9V AUDIO(R) COM-VIDEO-Pr-IN GND COM-VIDEO-Pb-IN S-VIDEO-SW COM-VIDEO-Y-IN GND INPUT0 SPDIF INPUT1 GND S-VIDEO-Y-IN VIDEO-IN S-VIDEO-C-IN GND 12.9 Q801 0 KTC3199-GR-AT/P 0 (AUDIO-MUTE) GND 1 2 3 4 4.6 0 4.6 0 C826 390P CN702 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 C817 820P O P 10-7 Q R FL11.0SCMB3 Main 4 Schematic Diagram [TYPE B] CAUTION ! Fixed voltage (or Auto voltage selectable) power supply circuit is used in this unit. If Main Fuse (F601) is blown , check to see that all components in the power supply circuit are not defective before you connect the AC plug to the AC power supply. Otherwise it may cause some components in the power supply circuit to fail. NOTE: The voltage for parts in hot circuit is measured using hot GND as a common terminal. CAUTION ! : For continued protection against risk of fire, replace only with same type 4 A, 125V fuse. ATTENTION : Utiliser un fusible de rechange de même type de 4A, 125V. 4A/125V CONTINUE MAIN 1 INV+31V PANEL+15V CONTINUE MAIN 3 PROTECT1 AMP(R)-OUT AMP(L)-OUT MAIN CBA 11.6 HOT CIRCUIT. BE CAREFUL. D903 OPEN R930 OPEN F601 4A/125V SA601 SURGE ABSORBER D601 1N5397BD D602 1N5397BD R602 1.2/3W D604 1N5397BD D603 1N5397BD 3 15 4 10 C921 OPEN C203 0.1 R404 OPEN 0 R676 22 R403 36K 9.9 R675 1K C633 1500P/1KV C603 270 /200V 16 D612 1ZB220-YBB 14 BC601 BEAD 13 6 12 D631 SB2A0BD C640 OPEN R655 470 C655 22/50V 0 0.4 R672 0.18/1W 13.3 Q201 R201 2SD400 5.6/1W 13.9 (SW+13V) D210 R207 R205 C202 D201 6.8K 1.5K 0.01 R208 6.8K D202 KIA431-AT/P D668 27BSB-T26 R213 27K 0.1 R609 1.5K 0 D610 C643 1000/25V C644 OPEN D636 FR104-B C636 100/25V C692 2200P/250V C608 1800P /100V D637 36BSB-T26 R631 12K D644 OPEN R221 22K -9.2 -8.5 R220 47K D204 C206 OPEN -9.1 Q206 KTC3199-GR-AT/P (SW-7.1V) R222 120 D641 SB360BH C201 470/25V R202 9.1K C652 1000 /6.3V R635 220 R670 270 6.9 Q639 KTA1267-QR-AT/P R666 6.1 (SWITCHING) 22K R203 510 D203 C656 0.1 24.3 Q205 24.9 KTC3199 -GR-AT/P R219 (SW+24.5V) 10 R216 2.7K R217 D205 2.7K 24BSC-T26 D206 R671 10 C651 OPEN D662 KIA431-AT/P R204 2.2K D661 OPEN 0.2 0 R665 3.9 R664 3.9 31.2 R674 10K R235 OPEN C205 OPEN R218 8.2K D660 WIRE R669 10K C661 3.3/50V R668 22K D411 6.7 Q635 2SC2120-Y (SW+5V) 6.8 5.2 5.9 6.8 R663 3.3 R690 3.3 C204 10/50V 0.7 Q638 KTC3199-GR-AT/P (SWITCHING) 5.9 5.2 Q637 2SC2120-Y 5.9 (SW+5V) D412 5.2 Q636 2SC2120-Y (SW+5V) C649 220/10V R632 1.1K R633 10K R662 39 R661 680 C648 47/25V D659 KIA431B-AT/P R660 10K R407 47K R406 47K 3.1 -1.3 R408 0 47K Q402 KTC3199 -GR-AT/P (SWITCHING) D405 C220 0.1 D207 7V5BSA-T26 C650 220/10V C221 0.1 R637 220 R636 OPEN 2 C645 2200P /100V 4 3 30.6 6.3 Q631 5.7 KTC3199 -GR-AT/P (FEED BACK) R658 D656 R638 2.7K 2.7K D648 HZS5.6NB2TE-EQ 1 R639 820 R646 820 R653 820 R654 820 R681 820 R645 7.5K R644 22K R643 22K R642 22K 6.4 Q634 R651 KTC3199 6.7 -GR-AT/P 15 (+5V REG) R652 R656 R650 R649 WIRE 680 680 680 D650 6V8BSA-T26 D647 OPEN R641 120 R640 18K 0.7 Q633 KTC3199-GR-AT/P (SWITCHING) D651 D652 OPEN R683 3.3/1W 5.0 Q643 R684 2SA950-Y 5.1 (SWITCHING) 3.3/1W 5.8 R689 33 D657 4V7BSB-T26 C647 100/10V IC631 LD1117V (+3.3V REG.) R682 WIRE D416 10BSB-T26 R413 22K R634 12K D403 OPEN 0.2 D655 FR154 R688 1 D654 FR154 31.8 D646 0 COLD D649 3V3BSB-T26 COM 1 30.6 R611 2.2K HOT R223 15K C685 0.1 R667 1K C646 0.1 C207 10/50V D645 C684 0.1 R698 OPEN 31.6 0.4 C607 0.082 /100V C681 0.1 D404 R699 56 R673 3.6K C641 3300/10V IC601 LTV817MCF ERROR VOLTAGE DET 13.3 R411 22K C683 0.1 3.3 Q640 2SC4881F 4.0 (SW+3.3V) 6.9 R212 22K R215 330 C691 4700P/250V 2 Q203 KTC3199 -GR-AT/P (SWITCHING) 0.7 R211 10K D643 FR252 D609 OPEN D410 15.4 D605 4V3BSB-T26 R612 220 R412 22K D408 5.2 C639 2200/10V 31.7 Q202 KTA1267 31.1 -QR-AT/P R214 (SWITCHING) 3.3K D608 D409 D667 OPEN 31.8 5.8 D653 C682 0.1 R608 R607 150 150 Q602 2SC2120-Y SWITCHING CONTROL R240 3.9K D642 R677 1K D406 D208 C605 1200P /100V D606 27BSB-T26 R209 56K R210 24.3 6.8K D209 0.4 Q210 KTC3199 R206 -GR-AT/P 0 47K (SWITCHING) C632 1000/35V D633 1ZB43BB C631 470/25V C604 0.039 /100V R239 150 R680 OPEN D407 R176 0 C638 2200/6.3V D640 OPEN D639 FR151-B/P R603 390K R604 390K R606 330K R605 390K D 134.0 Q601 G 5.8 TK5A50D (SWITCHING) S 0.2 C606 560P/2KV 7 D638 SB240-B/P C654 100/16V C653 22/50V D666 10BSB-T26 D665 WIRE D632 SB3200BR 9.2 Q641 KTC3199 -GR-AT/P (SW+9V) 4.7 0 Q172 KTC3199 0 -GR-AT/P (SWITCHING) R172 22K 0 0.6 Q171 KTC3199 0 -GR-AT/P (SWITCHING) R175 22K D901 OPEN 13.8 9 L601 LINE FILTER D607 39BSB-T26 R610 0.39/2W -3.7 Q401 KTC3199 -GR-AT/P (RESET) C401 1/50V C601 R601 0.47 1M /300V /1/2W 3 5.9 D402 R402 10BSB-T26 5.6K R401 D401 FR104-B 1 11 4A 125V R171 OPEN R932 OPEN R906 OPEN R173 OPEN R174 OPEN R685 620 R659 2.7 D670 /1/2W SB160 VIN 2 AC601 AC CORD D909 OPEN C910 OPEN Q905 OPEN (SW+9V) 10.3 VOUT 4 9.6 D908 OPEN C402 OPEN T601 POWER TRANS D902 OPEN 1 2 3 2.1 3.4 5.1 R405 OPEN C219 0.1 R647 R648 47K 10K R414 OPEN C218 0.1 R686 1K TO DIGITAL MAIN CBA UNIT CN3002 P-ON-H2 AUDIO(L)-OUT(NU) GND AUDIO(R)-OUT(NU) PROTECT3 AMP(L)-OUT GND AMP(R)-OUT P-ON-H1 P-ON+3V PROTECT1 GND LED-R P-ON+5V PROTECT2 P-ON+7V GND GND P-ON+3.3V P-ON+3.3V AL+3.3V AL+3.3V GND OE2 REMOTE BACKLIGHT-SW LED1 BACKLIGHT-ADJ VCOM-PWM CONTINUE MAIN 1 PROTECT3 BACKLIGHT-SW BACKLIGHT-ADJ CONTINUE MAIN 2 VCOM-PWM VCOM RESET PANEL+13V CONTINUE MAIN 3 LED1 REMOTE P-ON-H1-SW CONTINUE MAIN 2 TU-VT+31V TUNER+5V P-ON+9V DVD-M+10V(EV+9V DVD+5V AL+3.3V P-ON+5V CONTINUE MAIN 3 P-ON+5V P-ON+9V P-ON+3.3V AL+3.3V SP+14V TO LCD MODULE CN201 ASSEMBLY 1 GND 2 PANEL+13V 3 PANEL+13V 4 PANEL+24.5V 5 GND 6 PANEL+3.3V 7 PANEL+3.3V 8 PANEL-7.1V 9 GND 10 VCOM 11 GND CN301 3.3 1 0 2 0 3 0 4 3.3 5 2.6 6 0 7 2.6 8 3.2 9 3.4 10 2.1 11 0 12 0.6 13 5.2 14 0 15 6.9 16 0 17 0 18 3.3 19 3.3 20 3.3 21 3.3 22 0 23 0 24 3.3 25 3.2 26 0.6 27 0.9 28 0.7 29 UNLESS OTHERWISE SPECIFIED: DIODES ARE 1SS133. S T U V 10-8 W X Y FL11.0SCMB4 Main Schematic Diagram [TYPE C] CAUTION ! Fixed voltage (or Auto voltage selectable) power supply circuit is used in this unit. If Main Fuse (F601) is blown , check to see that all components in the power supply circuit are not defective before you connect the AC plug to the AC power supply. Otherwise it may cause some components in the power supply circuit to fail. 4A/125V BC1001 BEAD HOT CIRCUIT. BE CAREFUL. C1010 47/100V D1003 OPEN C1003 330/25V C1005 1/100V C1007 OPEN R1003 360K Q1001 RSD050N10TL (SWITCHING) 1 L601 LINE FILTER D612 1N5397BD D611 1N5397BD D609 1N5397BD D610 1N5397BD D601 1ZB220-YBB R629 390K 0 S C611 1200P 3.8 R627 390K 3 10 D619 SB3200BR C616 470/25V C608 220/200V 5 BC601 BEAD 6 8 7 R632A R631A OPEN OPEN R633 1.2K R1012 100 R635A R635 OPEN 2.2K C624 OPEN C622 220/10V D630 1ZB20BB R639 1.5K R639A OPEN D613 4V3BSB-T26 3.0 3 3.0 4 DRIVE D658 R674 5V6BSB-T26 22K 3.3 -2.4 C630 1/50V R1019 10K R1015 OPEN COMP 22 1.4 MCP 21 0 SEL 20 VIN 19 5.0 GND 18 0 D1004 27BSB-T26 R1025 OPEN R1023 1K R1032 240 NU 23 DRIVE R1033 240 R1013 100 C1013 0.47 R1027 OPEN R1026 OPEN D1005 Q1003 OPEN C1004 1 Q1002 OPEN R1028 OPEN R1029 OPEN R1030 18K R1031 18K DRIVE LDO 17 5.0 16 2.2 DRIVE DRIVE 1.4 10 OVP 1.3 11 ISET 1.1 12 RT R1009 20K R1010 1.5K C631 OPEN C627 10009/250V D657 SK16-T/R DRIVE R1020 100K C1012 470P 15 0 14 0 CONTROL LOGIC C1015 4.7 R1021 10K 13 3.0 C1017 R1022 100K 0.1 R1011 100K Q615 2SC2412K (SWITCHING) 0 R633A OPEN D616 D617 R634 0.68/2W OPEN R1006 10 24 1.3 0 8 0 9 R673 1 0.5 Q608 2SC2120-Y (SWITCHING) D620 1ZB30BB D627 SK16-TR C626 2200P/250V R632 R631 330 330 C633 470/25V C632 470/25V 2.5 1 3.0 2 C1016 1000P 3.0 5 DRIVE 0 6 GND 0 7 DRIVE C617 1500P /2KV D629 SK2B-T/R C623 470/25V C610 0.039 D614 27BSB-T26 0 D615 1ZB36BB 11 9 R630 390K Q607 TK5A50D (SWITCHING) G 3.8 12 2 R626 1.2/3W R628 390K C612 820P /2KV IC1001 HA7202PC LED BACKLIGHT DRIVER T601 POWER TRANS SA601 SURGE ABSORBER 170.5 D R1005 0 D1002 R1004 27K C1011 1000P R625 1M/1/2W 3 19.0 D G 2.1 S 0 R1007 0.24/1W C607 0.47/300V 4A 125V L1011 47uH D1001 SB1A0BB C1020 1/100V R1002 560K C1006 1/100V C1008 OPEN C1018 100P/2KV BC1002 BEAD C628 OPEN CN603 1 2 F601 4A/125V 2 C1001 C1002 1 1 C1019 OPEN 4 AC601 AC CORD NOTE: The voltage for parts in hot circuit is measured using hot GND as a common terminal. CAUTION ! : For continued protection against risk of fire, replace only with same type 4 A, 125V fuse. ATTENTION : Utiliser un fusible de rechange de même type de 4A, 125V. C613 0.082 R640A R683A OPEN OPEN R686 10K R680A R642A R681A OPEN OPEN OPEN IC601 TLP781F ERROR VOLTAGE DET 16.8 20.6 R680 R642 270 270 19.6 R641 OPEN 1 4 0.5 2 19.6 6.2 3 Q609 2SC2412K (FEED BACK) R656A OPEN D635 3V3BSB-T26 R681 270 R650 0 R649 0 R648 24K R647 22K C625 2200P 5.6 21.5 R656 15 R682A OPEN 5.6 R682 220 R643 3.9K Q610 2SC2412K (SWITCHING) BC001 BEAD HOT D634 5V6BSB-T26 R653 10K 17.6 0 0 R652 47K COLD R643A OPEN R646 820 R645 18K D641 D640 R657A OPEN (TO LCD MODULE) ILED3 ILED2 ILED4 ILED1 NU VLED CN601 2.1 19 3.3 18 2.8 17 3.2 16 3.0 15 3.3 14 3.3 13 3.4 12 0 11 0 10 5.4 9 0 8 11.5 7 11.5 6 0 5 21.5 4 21.5 3 0 2 0 1 TO DIGITAL MAIN CBA UNIT CN3701 VCOM-PWM(NU) BACKLIGHT-SW BACKLIGHT-ADJ PROTECT3 PROTECT1 P-ON-H1(NU) P-ON-H2 RESET GND GND AL+5V GND AMP+11V AMP+11V GND P-ON+21V P-ON+21V GND GND D664 5.3 Q611 KTC3198 -Y-AT/P (+5V REG) R657 WIRE D637 R684 56K D665 R685 6.8K D662 C637 C636 C635 C634 OPEN OPEN OPEN OPEN D663 D608 10BSB-T26 C638 OPEN R661A R655A R654A OPEN OPEN OPEN D642 D660 4V7BSB-T26 1 CN1001 3.0 1 3.0 2 3.0 3 3.0 4 5 45.5 6 R687 2.7K R636 220 C614 1000P (NO CONNECTION) VLED NU ILED1 ILED2 ILED3 ILED4 R676 OPEN R640 R683 OPEN OPEN D618 R636A OPEN R675 30K D631 OPEN CN1002 45.5 1 2 3.0 3 3.0 4 3.0 5 3.0 6 R661 220 R655 220 0.7 R623 22K D636 5V6BSB-T26 R677 R677A 22K OPEN 0 Q616 2SC2412K (SWITCHING) 0 R654 220 R624 22K Q631 2SC2412K (RESET) 0 0 C640 OPEN D661 GR1G 3.3 D638 OPEN C641 OPEN C639 OPEN C642 OPEN R679 10K JS1001 R678 47K C644 OPEN MAIN CBA UNLESS OTHERWISE SPECIFIED: DIODES ARE 1SS133. A B C D 10-9 E F G FL11.0SCMC Jack Schematic Diagram [TYPE B] BC841 BK1608HS601-T C843 0.1 4 3.6 JK841 DIGITAL AUDIO-OUT (COAXIAL) R844 220 C841 1 C845 33P C773 1 R847 10K R846 100 9.2 4.3 Q841 KTC3198-Y-AT/P (BUFFER) C842 1 R848 10K R845 100K BC771 BEAD R843 110 R788 82K C704 1 R712 100K C703 1 JK711 PC-AUDIO-IN 3 C723 1 R727 56K C724 1 R728 56K R721 100K JK722 HDMIAUDIO(R)-IN R722 100K IC771 TC4052BF(ELNF) (AUDIO SELECTOR) R791 82K R772 10K D702 EDZTE618.2B 5.1 1 5.1 2 VDD 16 9.0 15 5.1 D708 EDZTE618.2B 4.6 3 4.6 4 14 5.1 13 4.6 12 5.1 R792 100K HDMIAUDIO(L)-IN R790 82K R717 56K R711 100K JK721 R789 82K R718 56K R793 100K R794 100K R795 100K 5.1 5 0 6 INH 0 7 VEE 0 8 GND SW CTL C771 100/16V C772 0.1 R773 10K COMPONENTAUDIO(L)-IN JK742 C743 1 R747 56K C744 1 R748 56K R742 100K R784 100K R734 10 R731 75 C731 39P R732 75 C732 39P JK732 2 JK733 COMPONENT -Pr-IN R733 75 C751 OPEN 1 C752 OPEN R752 OPEN C753 100P R753 75 R754 100K JK754 AUDIO(R)-IN R755 100K C852 OPEN L853 WIRE L854 OPEN 0 D706 8V2BSB-T26 C734 0 R779 OPEN C735 0 R736 10 C736 0 0 Q771 KTC3199-GR-AT/P (INVERTER) 9.1 Q722 KTC3199-GR-AT/P (INVERTER) D709 8V2BSB-T26 R775 10K 0 CN701 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 R774 10K 0 R776 OPEN R778 OPEN 9.2 4.6 Q773 KTC3199-GR-AT/P C776 4.0 (BUFFER) 33P 9.2 4.6 R777 OPEN C775 Q774 4.0 33P KTC3199-GR-AT/P (BUFFER) R797 2.2K R796 2.2K R756 OPEN C754 OPEN R757 OPEN C755 OPEN C756 0 C757 1 R763 56K C758 1 R764 56K CN871 1 SP(L) 2 SP-GND D707 EDZTE618.2B JS701 0 D704 EDZTE618.2B C861 OPEN JACK CBA A C851 OPEN D705 8V2BSB-T26 R735 10 R758 10 JK753 AUDIO(L)-IN R787 100K R751 OPEN JK752 VIDEO-IN R786 100K JK851 HEADPHONE JACK C733 39P JK751 OPEN S-VIDEO-IN C Y SW R785 100K 9 9.2 D701 EDZTE618.2B JK731 COMPONENT -Pb-IN R783 82K R851 L851 180 WIRE 11 4.6 10 9.2 D710 EDZTE618.2B COMPONENT -Y-IN R782 82K D703 EDZTE618.2B R741 100K COMPONENTAUDIO(R)-IN R781 82K R852 L852 180 WIRE 9.2 JK741 R780 82K B C D 10-10 CN861A 1 2 3 4 TO MAIN CBA CN702 SP(R) SP(R) HEADPHONE(R) HEADPHONE(R) GND GND GND GND HEADPHONE(L) HEADPHONE(L) GND GND AUDIO(L) P-ON+9V AUDIO(R) COM-VIDEO-Pr-IN GND COM-VIDEO-Pb-IN S-VIDEO-SW COM-VIDEO-Y-IN GND INPUT0 SPDIF INPUT1 GND S-VIDEO-Y-IN VIDEO-IN S-VIDEO-C-IN GND SP861 SPEAKER L-CH (NO CONNECTION) SP(L) SP(L) SP-GND SP-GND E F FL11.0SCJB Function Schematic Diagram [TYPE A] 2 (NO CONNECTION) AL+3.3V GND KEY-IN1 CN4001 1 2 3 TO DIGITAL MAIN CBA UNIT CN3101 AL+3.3V GND KEY-IN1 CN4002 1 2 3 R4008 OPEN C4003 0.1 C4001 0.1 R4006 220 C4004 0.1 C4002 0.1 R4007 2.2K R4005 2.2K R4004 2.7K R4003 4.7K R4002 8.2K R4001 18K D4001 EDZTE615.6B SW4006 POWER SW4007 CH UP SW4005 CH DOWN SW4004 MENU SW4003 SOURCE SW4002 VOL UP SW4001 VOL DOWN 1 FUNCTION CBA UNIT UNLESS OTHERWISE SPECIFIED: SWITCHES ARE SKRMABE010. A B C 10-11 FL11.0SCFA Function Schematic Diagram [TYPE B] C107 1 R950 OPEN R107 3.3K R106 100 D103 L-53HT STANDBY D104 333GT/E POWER R108 220 R109 220 C106 OPEN C105 OPEN CN101B 1 2 3 4 5 6 7 8 RS101 KSM-712TH2E (REMOTE SENSOR) C950 OPEN VOUT Vcc GND 2 D950 OPEN DVD 1 2 3 TO MAIN CBA CN102 GND REMOTE AL+3.3V LED1 P-ON-H1 KEY-IN1 KEY-IN2 DVD-LED R110 1K D952 OPEN C103 47/16V C111 OPEN C110 OPEN C104 330P C109 0.1 D101 EDZTE61 6.8B 1 R111 18K R112 13K R113 2.7K R114 2.2K R115 2.2K R116 220 R118 10K SW104 VOL DOWN SW105 VOL UP SW106 MENU SW107 CH DOWN SW108 CH UP SW109 POWER R955 OPEN R954 OPEN R953 OPEN R952 OPEN SW954 OPEN AGING SW953 OPEN EJECT SW952 OPEN STOP SW955 OPEN PATTERN D105 0.1 C108 0.1 R956 OPEN R951 OPEN D951 OPEN SW951 OPEN PLAY C951 OPEN FUNCTION CBA UNLESS OTHERWISE SPECIFIED: SWITCHES ARE SKHHLMA010. A B C 10-12 FL11.0SCFB Function Schematic Diagram [TYPE C] 2 (NO CONNECTION) AL+3.3V GND KEY-IN1 CN4001 1 2 3 TO IR SENSOR CBA UNIT CN4051 AL+3.3V GND KEY-IN1 CN4002 1 2 3 R4008 OPEN C4003 0.1 C4001 0.1 D4002 OPEN R4006 220 C4004 0.1 C4002 0.1 R4007 2.2K R4005 2.2K R4004 2.7K R4003 4.7K R4002 8.2K R4001 18K D4001 EDZTE615.6B SW4006 POWER SW4007 CH UP SW4005 CH DOWN SW4004 MENU SW4003 SOURCE SW4002 VOL UP SW4001 VOL DOWN 1 FUNCTION CBA UNIT UNLESS OTHERWISE SPECIFIED: SWITCHES ARE SKRMAAE010. A B C 10-13 FL11.0SCFC IR Sensor Schematic Diagram [TYPE A] 2 R4051 100 C4054 0.1 R4052 3.3K R4054 1K C4055 OPEN VCC GND VOUT RS4051 GPIUSC32XP (REMOTE SENSOR) IC4051 OPEN D4051 19-21SURC /S530-A2/TR STANDBY 3 2 1 C4056 10 C4052 0.01 R4060 OPEN R4053 4.7K R4059 OPEN R4058 OPEN R4056 OPEN TO DIGITAL MAIN CBA UNIT CN3102 GND REMOTE AL+3.3V P-ON+5V LED1 KEY-IN1 LIGHT CN4051 1 2 3 (NO CONNECTION) AL+3.3V GND KEY-IN1 6 AMP 2 GND 5 LOGIC 3 VCC NU 4 1 R4057 OPEN C4051 10 R4055 OPEN CN4052 1 2 3 4 5 6 7 D4052 OPEN C4057 OPEN C4053 0.1 1 IR SENSOR CBA UNIT A B C 10-14 FL11.0SCIRA LED Schematic Diagram [TYPE C] IR Sensor Schematic Diagram [TYPE C] LED CBA UNIT 2 R4051 100 C4054 0.1 R4052 3.3K CN4052 1 2 3 4 5 6 7 R4054 1K C4055 OPEN VCC GND VOUT RS4051 GPIUSC32XP (REMOTE SENSOR) IC4051 OPEN D4051 19-21SURC /S530-A2/TR STANDBY 3 2 1 C4056 10 C4052 0.01 R4060 OPEN R4053 4.7K R4059 OPEN R4058 OPEN R4056 OPEN 1 C4101 0.1 D4101 SMLE12WBC7W1HR POWER R4101 4.7K 1 6 AMP 2 GND 5 LOGIC 3 VCC NU 4 R4057 OPEN C4051 10 R4055 OPEN TO DIGITAL MAIN CBA UNIT CN3102 GND REMOTE AL+3.3V P-ON+5V LED1 KEY-IN1 LIGHT TO DIGITAL MAIN CN4101 CBA UNIT CN3103 1 P-ON+5V 2 GND D4052 OPEN C4057 OPEN A B C4053 0.1 TO FUNCION CBA CN4051 UNIT CN4002 1 AL+3.3V 2 GND 3 KEY-IN1 1 IR SENSOR CBA UNIT A B C FL11.0SCIRC 10-15 FL11.0SCLC Digital Main 1 Schematic Diagram [TYPE A] 1 NOTE: The order of pins shown in this diagram is different from that of actual IC3005. IC3005 is divided into five and shown as IC3005 (1/5) ~ IC3005 (5/5) in this Digital Main Schematic Diagram Section. CONTINUE DIGITAL 4 VCOM-PWM 4 3 (NO CONNECTION) CN3011 LCD+5V 31 LCD+5V 30 LCD+5V 29 GND 28 GND 27 LCD+5V 26 LCD+5V 25 GND 24 NU 23 NU 22 D0(-) 21 D0(+) 20 D1(-) 19 D1(+) 18 GND 17 D2(-) 16 D2(+) 15 GND 14 CK(-) 13 CK(+) 12 D3(-) 11 D3(+) 10 NU 9 NU 8 GND 7 GND 6 GND 5 GND 4 NU 3 NU 2 NU 1 2 R3026 OPEN R3045 OPEN R3047 OPEN R3044 OPEN R3048 OPEN R3046 OPEN C3058 OPEN R3021 OPEN R3034 OPEN D3004 OPEN C3057 OPEN R3023 OPEN Q3007 OPEN C3019 OPEN R3022 OPEN Q3001 OPEN R3027 OPEN R3025 OPEN Q3002 OPEN C3054 OPEN 1 8 2 7 3 6 4 5 CONTINUE DIGITAL 4 P-ON+5V P-ON+24V P-ON+3.3V C3047 OPEN C3061 OPEN C3045 OPEN R3038 OPEN R3039 OPEN R3035 OPEN R3028 OPEN *1 IC3005(1/5) R8A05011BG-U0 DIGITAL SIGNAL PROCESS /MAIN MICRO CONTROLLER LVDS TX R16 R15 P14 P13 N16 N15 P16 P15 T16 T15 R14 T14 R13 T13 C3352 OPEN C3349 OPEN C3350 OPEN C3351 OPEN C3353 OPEN C3354 OPEN C3355 OPEN OPEN OPEN OPEN OPEN OPEN OPEN R3152 1K R3511 22 C3161 C3162 C3163 C3164 C3165 R3041 1 L13 M15 L16 L15 M14 L14 M16 M13 N14 N13 K15 R3088 7.5K CN3006 (NO CONNECTION) 30 LCD+21V 29 LCD+21V 28 GND 27 VCOM-PWM 26 PWR-CTRL 25 P-ON+3.3V 24 GND 23 LLV0(+) 22 LLV0(-) 21 LLV1(+) 20 LLV1(-) 19 LLV2(+) 18 LLV2(-) 17 GND 16 LLVCNK(+) 15 LLVCLK(-) 14 GND 13 LLV3(+) 12 LLV3(-) 11 LLV4(+) 10 LLV4(-) 9 LLV5(+) 8 LLV5(-) 7 GND 6 TP 5 POL 4 CPV 3 OE1 2 XA0 1 STV CN3005 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 TO DIGITAL MAIN 2 IC3005(2/5) TP POL CPV OE STV NU NU NU CELL-PWR-CTRL NU NU R3037 OPEN TO LCD MODULE ASSEMBLY GND LLV0(+) LLV0(-) LLV1(+) LLV1(-) LLV2(+) LLV2(-) GND LLVCNK(+) LLVCLK(-) GND LLV3(+) LLV3(-) LLV4(+) LLV4(-) LLV5(+) LLV5(-) GND TP POL CPV OE1 XA0 STV R3036 OPEN DIGITAL MAIN CBA UNIT A B C D 10-16 E F FL11.0SCDA1 Digital Main 2 Schematic Diagram [TYPE A] 1 NOTE: The order of pins shown in this diagram is different from that of actual IC3005. IC3005 is divided into five and shown as IC3005 (1/5) ~ IC3005 (5/5) in this Digital Main Schematic Diagram Section. 4 5 D3405 1SS400 4 C3408 D3401 OPEN OPEN C3410 10P C3407 0.1 L3401 2.2uH C3401 10 R3418 0 C3175 OPEN D3402 OPEN C3411 10P C3404 100P R3417 OPEN C3176 OPEN C3405 33P IC3012 AT24C02C-SSHM-T (MEMORY) R3204 4.7K 2 R3203 4.7K 3 GND D3404 OPEN R3338 0 DEMODULATOR /MPEG DECODER A12 IF-AGC A16 NU D1 R3354 0 C3226 OPEN C3225 OPEN R3194 0 C3178 0.1 C3177 OPEN Q3012 2SK3018T106 (BUFFER) R3296 100 1 A0 VCC 8 2 A1 WP 7 3 A2 SCL 6 4 GND SDA 5 C3211 0.1 R3310 10K Q3034 2SC4081UBTLQ (SWITCHING) R3361 OPEN NU NU NU NU 2 R3326 4.7K R3321 4.7K D3041 OPEN D3054 OPEN R3360 OPEN R3339 100 L3023 C3242 R3368 OPEN OPEN OPEN R3285 0 R3286 0 0.01 0.1 0.1 0.1 R3358 10K D3050 OPEN R3347 10K D3045 OPEN R3356 OPEN D3049 OPEN R3364 OPEN D3053 OPEN R3377 OPEN D3055 OPEN R3192 4.7K R3401 0 R3193 4.7K Q3702 OPEN VGA-SCL G14 VGA-SDA F14 C3197 0.1 C3335 2.2 OUT C WF1 R3403 0 R3402 0 NU B10 NU A11 NU D10 11 6 1 12 7 2 13 8 3 14 9 4 15 10 5 CONTINUE DIGITAL 3 EDID-WPB COMP-DET DIGITAL SIGNAL PROCESS TO DIGITAL TO DIGITAL MAIN 5 MAIN 1 IC3005(5/5) IC3005(1/5) JK3001(REAR) PC-RGB-IN D3040 1SS400TE61 R3376 100 R3343 100 C3194 0.1 C3195 0.1 C3196 0.1 C3198 C3199 C3200 C3201 CONTINUE DIGITAL 4 P-ON+3.3V P-ON+5V PROTECT1 P-ON-H1 56P 56P 56P 75 75 75 A/D CONVERTER C10 C9 D8 B11 A10 C8 D9 B9 R3413 30K C3412 OPEN R3456 4.7K R3455 4.7K C3287 C3288 C3289 C3291 C3292 C3293 SW R3412 100K R3411 2K D3027 1SS400TE61 R3284 0 VGA-HSYNC A14 VGA-VSYNC B14 A9 C7 C11 5 R3410 4.7K C3235 OPEN R3353 0 R3337 0 R3202 2.7K R3205 18K L3022 OPEN 4 4 R3298 100 R3206 22 R3207 22 3 C3413 OPEN Q3011 2SK3018T106 (BUFFER) R3369 L3024 C3243 OPEN OPEN OPEN SCL R12 SDA T12 B12 TO DIGITAL MAIN 5 IC3005(5/5) C3406 33P R3407 OPEN *1 IC3005(2/5) R8A05011BG-U0 DIGITAL SIGNAL PROCESS /MAIN MICRO CONTROLLER 3 D3403 OPEN C3409 0.1 2 4 IC3014 74LVC1G126GW (BUFFER GATE) 1 VCC 5 R3414 OPEN 1 C3214 0.1 3 GND C3402 0.1 C3403 0.1 GND 7 2 VCC DIF-OUT1 6 DIF-OUT2 3 IF-AGC SCL SDA GND +3.3V 2 1 IC3013 74LVC1G126GW (BUFFER GATE) 1 VCC 5 CTL IC3401 BD7820FP-E2 (+3.3V REG.) TU3401 TUNER UNIT C3272 OPEN C3271 OPEN R3706 18K R3719 0 C3285 0.1 C3286 0.1 C3336 1 C3710 OPEN R3717 OPEN R3714 OPEN R3707 18K C3701 39P R3701 75 C3702 39P R3702 75 C3703 39P R3703 75 C3704 1 R3704 100K C3705 1 R3705 100K JK3701(REAR) COMPONENT-Y /VIDEO-IN WF2 COMPONENT -Pb-IN WF3 COMPONENT -Pr-IN WF4 AUDIO(L)-IN AUDIO(R)-IN Q3703 OPEN C3708 0.1 1 9.2 3.8 JK3702(REAR) DIGITAL AUDIO-OUT (COAXIAL) G R3709 220 C3706 1 C3709 100P C3713 R3715 OPEN OPEN R3711 10K C3712 R3713 OPEN OPEN R3710 C3707 0 1 4.3 Q3701 R3712 2SC4081UBTLQ 10K (BUFFER) R3708 110 R3720 0 C3711 OPEN CONTINUE DIGITAL 5 AUDIO(L)-IN AUDIO(R)-IN R3716 OPEN R3718 OPEN CONTINUE DIGITAL 5 SPDIF DIGITAL MAIN CBA UNIT H I J 10-17 K L FL11.0SCDA2 Digital Main 3 Schematic Diagram [TYPE A] 1 NOTE: The order of pins shown in this diagram is different from that of actual IC3005. IC3005 is divided into five and shown as IC3005 (1/5) ~ IC3005 (5/5) in this Digital Main Schematic Diagram Section. *1 IC3005(3/5) R8A05011BG-U0 DIGITAL SIGNAL PROCESS /MAIN MICRO CONTROLLER C3009 0.1 R3064 100 R3065 100 4 OPEN 0.1 OPEN 0.1 OPEN 0.1 OPEN 0.1 OPEN 0.1 OPEN 0.1 OPEN *A VDD VREF J2 C3010 0.1 1-O3 2-O3 3-O3 SD-DQ15 SD-DQ14 SD-DQ13 SD-DQ12 SD-DQ11 SD-DQ10 SD-DQ9 SD-DQ8 3 4-O3 5-03 6-O3 SD-DQ7 SD-DQ6 SD-DQ5 SD-DQ4 SD-DQ3 SD-DQ2 SD-DQ1 SD-DQ0 CKE CK CK CS RAS CAS WE BA2/NU BA1 BA0 A12 A11 A10/AP A9 A8 A7 A6 A5 A4 A3 A2 A1 A0 ODT K2 J8 K8 L8 K7 L7 K3 L1 L3 L2 R2 P7 M2 P3 P8 P2 N7 N3 N8 N2 M7 M3 M8 K9 E2 A2 R8 R7 R3 NU NU NU NU NU B7 A8 B3 B9 B1 D9 D1 D3 D7 C2 C8 F7 E8 F3 F9 F1 H9 H1 H3 H7 G2 G8 UDQS UDQS/NU UDM DQ15 DQ14 DQ13 DQ12 DQ11 DQ10 DQ9 DQ8 LDQS LDQS/NU LDM DQ7 DQ6 DQ5 DQ4 DQ3 VSS *B DQ2 *A:A1,A9,C1,C3,C7,C9,E1,E9, G1,G3,G7,G9,J1,J9,M9,R1 DQ1 DQ0 *B:A3,A7,B2,B8,D2,D8,E3,E7, F2,F8,H2,H8,J3,J7,N1,P9 R3049 100 1 CS VCC 8 2 SO NU 7 3 WP SCK 6 4 GND SI 5 R3031 1 CN3009 1 2 3 4 C3246 1 D3052 OPEN 15 6.8 6.8 15 15 15 15 150 15x4 15x4 R3032 15x4 R3033 15x4 R3102 10K R3107 10K R3089 R3092 R3093 R3094 R3095 R3096 47 47 47 47 22 0 C3348 100/16V R3099 5.6K IC3019 BD2224G-TR (EEPROM) 1 VIN VOUT 5 L3025 EXC24CG900U C3327 0.1 M5 SD-VREF0 N3 GND C3184 16P XIN25 H15 XOUT25 H16 R3223 1K R8 N8 P7 R6 P6 N7 T5 P8 P4 T3 R4 T2 P3 T4 R3 N4 T6 R5 T7 R7 N5 P5 SD-DQ15 SD-DQ14 SD-DQ13 SD-DQ12 SD-DQ11 SD-DQ10 SD-DQ9 SD-DQ8 SD-DQ7 SD-DQ6 SD-DQ5 SD-DQ4 SD-DQ3 SD-DQ2 SD-DQ1 SD-DQ0 SD-UDM SD-LDM SD-UDQSN SD-UDQS SD-LDQSN SD-LDQS L4 R1 R2 L3 H2 H1 N2 H4 M2 N1 M3 P1 K2 L2 M1 L1 J2 K3 K1 J1 J3 H3 J4 K4 SD-WE SD-CLKN SD-CLK SD-CKE SD-A8 SD-A4 SD-BA0 NU SD-A12 SD-A7 SD-A3 SD-BA2 SD-ODT SD-A9 SD-A5 SD-A1 SD-A11 SD-A6 SD-A2 SD-A0 SD-RAS SD-CAS SD-A10 SD-BA1 P12 R11 P11 T11 T9 R9 R10 T10 P10 CS SOUT SIN SCK EN OC USBDP USBDN NU ASEBRKAK-N ASEMD0 TRST-N TCK TDI TDO TMS X3001 25MHz C3183 16P F15 F16 E16 E15 D16 D15 E14 R3522 10K R3395 4.7K TXD0 RXD0 NU NU NU M32-TCK NU BACKLIGHT-ADJ VCOM-PWM GND G15 G16 G1 F1 G2 E1 G3 F3 F2 J14 R3468 100 R3469 100 R3396 4.7K B16 K14 K16 C1 BACKLIGHT-SW E2 R3516 100 R3517 100 COMP-DET N12 CN3010 1 2 3 4 (NO CONNECTION) P-ON+5V UART0-TX UART0-RX GND CONTINUE DIGITAL 5 CPU-RESET-N CONTINUE DIGITAL 4 GPY10 CPU-RESET-N P-ON-H2 DTV-ON-H2 DTV-ON-H1 P-ON-H1 BACKLIGHT-ADJ BACKLIGHT-SW VCOM-PWM R3211 R3514 R3210 100 100 100 R3188 22 R3503 10K LED1 J16 AUDIO-MUTE G13 REMOTE C14 (NO CONNECTION) AL+3.3V GND ASEBRKAK-N ASEMD0 TRST-N TCK TDI TDO TMS CPU-RESET-N CONTINUE DIGITAL 2 EDID-WPB COMP-DET R3510 22 NU F13 GPY10 E13 P-ON-H2 DTV-ON-H2 DTV-ON-H1 P-ON-H1 CN3012 1 2 3 4 5 6 7 8 9 10 CONTINUE DIGITAL 5 LED1 AUDIO-MUTE REMOTE R3515 4.7K R3233 22 R3213 22 R3234 10K R3215 R3201 33K 22 CONTINUE DIGITAL 4 P-ON+1.8V P-ON+3.3V AL+3.3V P-ON+5V C3073 0.1 R3479 10K (USB JACK) BUS-POWER USBDN USBDP GND 3-M3 6-M3 2-M3 1-M3 5-M3 4-M3 R3050 R3024 R3015 R3016 R3040 R3029 R3020 R3070 R3030 2 IC3006 W25Q32BVSSIG (MEMORY) C3051 0.1 SD-DQ15 SD-DQ14 SD-DQ13 SD-DQ12 SD-DQ11 SD-DQ10 SD-DQ9 SD-DQ8 SD-DQ7 SD-DQ6 SD-DQ5 SD-DQ4 SD-DQ3 SD-DQ2 SD-DQ1 SD-DQ0 IC3002 K4T51163QI-HCF7 (DDR2 SDRAM) C3029 C3030 C3031 C3032 C3033 C3034 C3035 C3036 C3037 C3038 C3039 C3040 C3041 C3050 0.1 NU H14 C3072 10 C3071 0.1 2 GND 3 /EN /OC 4 R3480 10K L3041 BEAD DIGITAL MAIN CBA UNIT M N O P 10-18 Q R FL11.0SCDA3 Digital Main 4 Schematic Diagram [TYPE A] 1 NOTE: The order of pins shown in this diagram is different from that of actual IC3005. IC3005 is divided into five and shown as IC3005 (1/5) ~ IC3005 (5/5) in this Digital Main Schematic Diagram Section. DIGITAL MAIN CBA UNIT C3125 OPEN C3126 0.1 C3127 OPEN C3128 0.1 C3129 OPEN C3134 C3132 10 10 L3020 220uH C3133 10 L3001 2.2uH R3084 2.2K C3155 1 C3139 0.1 C3325 OPEN C3324 OPEN C3343 10 C3264 0.01 C3322 OPEN C3321 10 C3320 OPEN C3319 10 C3114 OPEN C3318 10 C3140 OPEN C3141 0.1 C3142 OPEN C3143 0.1 C3144 OPEN C3145 0.1 C3081 1 C3082 0.1 L3019 220uH C3149 0.1 C3150 0.1 C3091 1000P C3117 0.1 L3026 220uH R3141 10 C3085 0.1 L3029 C3154 BEAD 0.1 VCCQ33 VCCQ33 VCCQ33 VCCQ33 VCCQ33 AVDD33 G4 F5 L12 K13 J12 N11 C3158 OPEN EN 7 COMP 6 FB 5 R3134 10K R3137 6.8K C3159 0.1 C3089 D3001 OPEN OPEN R3051 OPEN C3012 0.1 C3168 OPEN C3092 1000P R3052 10 C3090 1 C3094 330/4V C3067 330/4V C3097 10 C3096 10 C3066 330/4V 3 SW C3068 OPEN C3093 D3002 OPEN OPEN R3053 OPEN C3065 10 D3006 EDZTE615.6B C3026 0.1 C3025 1 C3095 1000P *C:G5,G6,H6,J7,J11,J13,K6,K7, K11,L8,L9,M9,N9,P9,M11. *D:D2~D5,D12,E3~E5,E7,E9,F4,F6, F7,F10,F11,G7~G10,H7~H13,J6, J8~10,K5,K8~K10,K12,L5~L7, L10,L11,P2,T8 R3054 10 C3042 0.1 C3022 IC3003 4.7 MP2303ADNLFZ (DC-DC CONVERTER) C3028 0.1 1 BST SS 8 2 VIN 3 SW 4 GND 1 3 4 5 C3070 0.1 R3110 1K R3109 820 C3079 100/4V C3087 10 C3167 OPEN R3111 C3075 1.2K OPEN C3001 100/35V C3109 10 C3110 10 C3111 10 C3112 10 C3170 OPEN L3013 0 C3101 10 C3021 10 R3004 22K R3003 0 C3062 10 C3063 10 D3005 EDZTE615.6B IC3601 AP2121AK-3.3TRE1 (+3.3V REG.) C3171 OPEN 1 2 3 4 5 C3146 0.1 C3138 1 C3153 1 C3011 1 C3046 1 C3052 1 COMP 6 R3005 3.3K FB 5 R3072 100 C3074 10 C3056 10 R3012 15K R3007 10K C3601 0.1 C3602 100/4V C3104 10 C3603 1 C3015 10 C3016 0.1 C3044 0.1 D3007 EDZTE615.6B R3006 4.7K S T CONTINUE DIGITAL 3 GPY10 CPU-RESET-N P-ON-H2 DTV-ON-H2 DTV-ON-H1 P-ON-H1 BACKLIGHT-ADJ BACKLIGHT-SW VCOM-PWM C3017 0.015 C3020 220/6.3V U V 10-19 CONTINUE DIGITAL 5 RESET PROTECT1 PROTECT3 CONTINUE DIGITAL 5 AL+3.3V P-ON+5V P-ON+3.3V(1) AMP+11V R3002 6.8K C3043 0.015 C3053 220/6.3V CONTINUE DIGITAL 1 P-ON+5V P-ON+24V P-ON+3.3V EN 7 L3005 22uH C3098 D3003 OPEN OPEN R3055 OPEN C3105 4.7 C3086 10 2 C3069 10 R3143 15K VSS *D C3263 1 R3001 6.8K FB 5 L3002 22uH C3064 10 R3061 1K 1 C3018 1 COMP 6 R3060 470 R3059 180 IC3007 BD7820FP-E2 (+1.8V REG.) EN 7 2 VIN C3014 0.1 4 GND R3149 180 R3145 8.2K C C3049 100/4V C3131 1 C3002 C3102 C3166 4.7 4.7 OPEN IC3001 MP2303ADNLFZ (DC-DC CONVERTER) C3013 0.1 R3010 SS 8 1 BST 0 C3007 1 R3133 10K C3088 0.015 L3009 22uH C3152 0.1 L3016 220uH C3157 0.1 3 SW 4 GND AVDD33 E6 C3151 0.1 2 VIN C3169 OPEN VOUT C3148 0.1 C3103 4.7 NU C3147 1 C3080 4.7 IC3008 MP2303ADNLFZ (DC-DC CONVERTER) C3083 0.015 SS 8 1 BST CE E10 C2 C3 E11 D6 C3326 OPEN GND 2 AVDD33 AVDD33 AVDD33 AVDD33 AVDD33 H5 J5 M4 T1 M6 N6 M7 M8 C3076 BC3001 2.2uH 10 L3014 220uH VIN VCCQ18 VCCQ18 VCCQ18 VCCQ18 VCCQ18 VCCQ18 VCCQ18 VCCQ18 C3027 0.1 Q3004 2SC4081UBTLQ (SWITCHING) L3028 220uH VDDCLK G11 5 C3024 10 Q3003 2SC4081UBTLQ (SWITCHING) R3079 10K C3156 1 4 R3086 2.2K R3077 10K L3021 220uH C3137 1 C3023 OPEN C3108 100/16V 3 C3055 C3060 C3059 C3048 C3005 C3004 C3006 C3003 C3136 0.1 D3104 1SS400TE61 D3106 1SS400TE61 D3101 1SS400TE61 D3102 1SS400TE61 2 100 100 100 100 100 100 100 C3124 0.1 1 R3019 R3018 R3068 R3013 R3009 R3011 R3008 C3123 0.1 R3097 2.2K Q3005 2SC4081UBTLQ (SWITCHING) CONTINUE DIGITAL 2 P-ON+3.3V P-ON+5V PROTECT1 P-ON-H1 1000P 1000P 1000P 1000P 100P 1000P 1000P 100P C3122 OPEN R3423 47K IC3004 BD7820FP-E2 (+1.2V REG.) R3424 100 C3265 D3103 1SS400TE61 10 C C3121 OPEN Q3101 2SC4081UBTLQ (SWITCHING) OUT R3105 Q3006 2SA1576UBTLQ 1K (SWITCHING) L3015 220uH C3135 0.1 D3105 OPEN OUT Q3013 SSM3K309T (SW+12V) AVDD12 M10 R3100 22K R3464 OPEN GND R3106 22K S GND D VDD12 *C AVDD12 E8 AVDD12 F8 AVDD12 F9 L3027 220uH G VCC C3182 0.1 C3160 0.1 VCC R3222 10K R3220 0 CTL VCC33STB F12 VCC33STB G12 VDD12STB E12 L3030 BEAD C3181 0.1 3 CONTINUE DIGITAL 3 P-ON+1.8V P-ON+3.3V AL+3.3V P-ON+5V R3221 100 CTL 4 *1 IC3005(4/5) R8A05011BG-U0 DIGITAL SIGNAL PROCESS /MAIN MICRO CONTROLLER W CONTINUE DIGITAL 1 VCOM-PWM CN3701 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 TO MAIN CBA CN301 VCOM-PWM BACKLIGHT-SW BACKLIGHT-ADJ PROTECT3 PROTECT1 P-ON-H1 P-ON-H2 RESET GND GND AL+5V GND AMP+11V AMP+11V GND P-ON+24V P-ON+24V GND GND X FL11.0SCDA4 Digital Main 5 Schematic Diagram [TYPE A] 1 NOTE: The order of pins shown in this diagram is different from that of actual IC3005. IC3005 is divided into five and shown as IC3005 (1/5) ~ IC3005 (5/5) in this Digital Main Schematic Diagram Section. CONTINUE DIGITAL 5 AL+3.3V P-ON+5V P-ON+3.3V(1) AMP+11V DIGITAL MAIN CBA UNIT R3183 OPEN C3557 OPEN C3558 OPEN R3185 OPEN LED1 AUDIO-MUTE REMOTE R3236 560 CN3102 1 2 3 4 5 6 7 R3552 100 C3553 100P (NO CONNECTION) CN3103 P-ON+5V 1 GND 2 TO FUNCTION CBA UNIT CN4002 AL+3.3V GND KEY-IN1 C3555 100P CN3101 1 2 3 Q3501 2SC4081UBTLQ (SWITCHING) HDMI I/F C3551 1000P R3554 100 C3552 1000P CONTINUE DIGITAL 4 RESET PROTECT1 PROTECT3 C3554 1000P R3312 R3313 R3314 R3315 R3316 R3341 C3217 C3218 C3223 C3224 R3340 C3219 C3220 C3216 R3335 100 R3336 100 R3322 560 R3325 560 D3813 1SS400TE61 10K 22 22 OPEN 22 0 10 10 10 10 10K 10 10 10 R3812 2.2K C3812 100/16V C3809 1 R3811 R3810 560 27K R3817 D3805 1SS400TE61 15K R3813 560 R3806 10K R3814 27K R3818 15K C3816 6800P C3813 100/16V DRIVE 2 GND 3 RIPPLE FILTER C3817 C3810 6800P 1 R3803 10K 1 R3842 47K C3833 0.1 C3834 OPEN Q3201 2SK3018T106 (BUFFER) R3217 4.7K R3277 47K C3273 OPEN R3302 10K R3274 47K C3260 R3409 1 47K NU 14 6 NU 13 AUDIO I/F NU NU NU NU NU NU SPDIF N10 R3386 10K R3209 100 R3380 10K R3378 10K Q3031 2SA1576UBTLQ (SWITCHING) R3379 10K TO DIGITAL MAIN 2 IC3005(2/5) R3385 10K CPU-RESET-N J15 9 C3261 OPEN Q3033 2SC4081UBTLQ (SWITCHING) Q3032 2SC4081UBTLQ (SWITCHING) R3809 300 D3804 1SS400TE61 DRIVE Z CD 3 C3252 OPEN R3182 4.7K C3116 OPEN C3120 0.01 C3113 0.033 R3732 180 R3731 180 NU 10 C3731 OPEN JK3731 HEADPHONE JACK C3732 OPEN L3731 OPEN R3823 1M R3827 10K D3808 MM5Z20B R3825 470K C3835 4.7 Q3805 2SC4081UBTLQ (SWITCHING) C3802 OPEN CN3802 1 SP(R) 2 SP-GND SP862 SPEAKER R-CH C3801 OPEN CN3801 1 SP(L) 2 SP-GND SP861 SPEAKER L-CH C3818 100/25V R3815 470 C3806 100/25V C3808 0.022 R3805 8.2 IC3009 PST8420UR (RESET) 1 GND OUT 4 NU 11 C3805 100/25V R3816 470 R3178 10K 2 VDD C3106 0.1 CONTINUE DIGITAL 2 SPDIF CONTINUE DIGITAL 3 CPU-RESET-N D3108 EDZTE615.6B C3819 100/25V C3807 0.022 R3804 8.2 HDMICONNECTOR-1 TMDS-D2(+) D-SHIELD0 TMDS-D2(-) TMDS-D1(+) D-SHIELD1 TMDS-D1(-) TMDS-D0(+) D-SHIELD2 TMDS-D0(-) TMDS-CLOCK(+) C-SHIELD0 TMDS-CLOCK(-) HDMI-CEC NU HDMI-CLOCK HDMI-DATA GND +5V HOT PLUG DETECT R3374 1K R3191 100 NU 12 MUTE CONTROL JK3004 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 R3301 18K NU 15 Q3801 2SC4081UBTLQ (AUDIO-MUTE) R3808 3.3K Y C3274 OPEN PWR M12 NU 17 5 GND 8 R3820 4.3K AUDIO DECODER NU 16 4 R3819 4.7K R3822 OPEN NU KEY-IN1 PROTECT3 LIGHT-SENS PROTECT1 LPF NU 18 1 7 VCC C3811 0.1 D13 A15 B13 A13 C13 C12 A8 B8 B7 A7 D11 D7 C6 C5 B6 A6 HDMI-SCL C16 HDMI-SDA C15 HDMI-HPD D14 IC3801 TDA1517P (AUDIO AMP) D3814 EDZTE616.2B 2 Q3202 2SK3018T106 (BUFFER) R3216 4.7K C3301 OPEN C3231 0.22 CONTINUE DIGITAL 2 AUDIO(L)-IN AUDIO(R)-IN R3271 C3188 3K 2200P B1 A1 B2 A2 B3 A3 B4 A4 D3107 1SS400TE61 C3229 R3502 C3227 R3501 C3233 R3500 C3232 R3499 3 R3553 100 C3559 1000P C3556 1000P C3186 4700P R3555 OPEN R3551 100 R3415 82K D3057 RB751S-40 C3185 R3270 C3187 0.01 2.2K 2.2 EXT-RES C4 PLL-XFC-A B5 PLL-XFC-P A5 VIDEO DECODER R3405 100 R3237 27K HDMI-CEC B15 TO DIGITAL MAIN 2 IC3005(2/5) R3186 OPEN R3317 10K R3318 10K R3319 10K TO IR SENSOR CBA UNIT CN4052 GND REMOTE AL+3.3V P-ON+5V LED1 KEY-IN1 LIGHT R3184 OPEN 330P OPEN 330P OPEN OPEN OPEN OPEN OPEN 4 *1 IC3005(5/5) R8A05011BG-U0 DIGITAL SIGNAL PROCESS /MAIN MICRO CONTROLLER Q3010 OPEN CONTINUE DIGITAL 3 Q3014 2SK3018T106 (BUFFER) D3809 MM5Z20B R3824 1M R3828 10K AA BB 10-20 CC DD FL11.0SCDA5 Digital Main 1 Schematic Diagram [TYPE B] 1 NOTE: The order of pins shown in this diagram is different from that of actual IC3005. IC3005 is divided into six and shown as IC3005 (1/6) ~ IC3005 (6/6) in this Digital Main Schematic Diagram Section. DIGITAL MAIN CBA UNIT 4 8 7 6 5 1 2 3 4 Q3002 OPEN R3006 OPEN R3002 OPEN R3001 OPEN R3561 R3560 R3559 R3558 R3557 R3556 R3555 R3554 R3553 R3552 OPEN OPEN OPEN OPEN OPEN OPEN OPEN OPEN OPEN OPEN R3545 R3544 0 0 R3007 OPEN C3002 OPEN Q3001 OPEN *1 IC3005(1/6) R8A05011BG-U0 DIGITAL SIGNAL PROCESS /MAIN MICRO CONTROLLER R16 R15 P14 P13 N16 N15 P16 P15 T16 T15 R14 T14 R13 T13 2 TO DIGITAL MAIN 2 IC3005(2/6) TP POL CPV OE STV NU NU R3551 R3550 R3549 R3548 R3547 R3546 R3543 R3542 R3541 R3540 R3539 R3538 C3349 OPEN C3350 OPEN C3351 OPEN C3353 OPEN C3354 OPEN C3355 OPEN 0 0 0 0 0 0 0 0 0 0 0 0 R3537 R3536 R3535 R3534 L13 M15 L16 L15 M14 M16 M13 NU K15 0 0 0 0 R3533 0 OPEN OPEN OPEN OPEN OPEN OPEN LVDS TX 1 C3352 OPEN R3567 R3566 R3565 R3564 R3563 R3562 3 C3345 OPEN R3088 7.5K (NO CONNECTION) LCD+12V LCD+12V LCD+12V LCD+12V LCD+12V GND GND GND LLV0(+) LLV0(-) LLV1(+) LLV1(-) LLV2(+) LLV2(-) GND LLVCNK(+) LLVCLK(-) GND LLV3(+) LLV3(-) NU NU NU NU GND NU NU NU NU NU NU CN3005 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 TO LCD MODULE ASSEMBLY GND LLV0(+) LLV0(-) LLV1(+) LLV1(-) LLV2(+) LLV2(-) GND LLVCNK(+) LLVCLK(-) GND LLV3(+) LLV3(-) LLV4(+) LLV4(-) LLV5(+) LLV5(-) GND TP POL CPV OE1 XA0 STV CONTINUE DIGITAL 5 P-ON+3.3V CONTINUE DIGITAL 2 RESET-LCD LESET LCD N14 NU N13 CONTINUE DIGITAL 5 OE2 LCD+12V OE2 L14 A R3152 1K CN3011 31 30 29 28 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 B C D 10-21 E F FL11.0SCDB1 Digital Main 2 Schematic Diagram [TYPE B] 1 NOTE: The order of pins shown in this diagram is different from that of actual IC3005. IC3005 is divided into six and shown as IC3005 (1/6) ~ IC3005 (6/6) in this Digital Main Schematic Diagram Section. R3144 100 R3142 100 R3138 100 DIGITAL MAIN CBA UNIT 4 *1 IC3005(2/6) R8A05011BG-U0 DIGITAL SIGNAL PROCESS /MAIN MICRO CONTROLLER TO DIGITAL MAIN 3 IC3005(3/6) C3243 R3369 OPEN OPEN L3024 OPEN B12 R3338 0 DEMODULATOR /MPEG DECODER A12 L3022 0.27uH D3056 OPEN IC3012 AT24C02BN-SH-T (MEMORY) R3353 0 R3202 2.2K C3178 0.1 R3360 OPEN L3023 OPEN R3194 0 1 A0 C3242 R3368 OPEN OPEN C3084 OPEN C3177 OPEN R3134 100 C3086 1000P Q3011 OPEN C3235 33P R3337 0 IF-AGC A16 C3087 33P R3404 100 R3192 4.7K R3361 OPEN R3354 0 C3226 10P C3225 10P R3193 4.7K Q3012 OPEN VCC 8 2 A1 WP 7 3 A2 SCL 6 4 GND SDA 5 C3074 OPEN C3211 0.1 R3310 OPEN R3326 4.7K R3321 4.7K R3333 100 R3334 100 D3054 OPEN HDMA-SCL G14 HDMI-SDA F14 D3041 OPEN C3092 1000P C3089 33P C3093 33P C3095 33P C3098 33P R3450 OPEN 3 R3511 22 R3187 22 R3091 OPEN INPUT0 G1 INPUT1 D1 S-VIDEO-SW N12 R3513 10K R3156 100 R3172 100 C3099 100P R3189 10K C3101 100P C3100 33P C3102 33P C3103 OPEN R3175 100 C3104 OPEN A/D CONVERTER B9 DIGITAL SIGNAL PROCESS 3 GND 4 IC3014 SN74LVC1G126DCKR (BUFFER GATE) 1 VCC 5 3 GND C3197 0.1 C3335 2.2 R3403 R3402 R3401 R3400 R3399 0 0 0 OPEN OPEN D3027 1SS400TE61 D3040 1SS400TE61 R3343 100 R3339 100 C3285 0.1 C3286 0.1 C3336 1 R3285 47 R3286 47 Q3010 OPEN TO DIGITAL TO DIGITAL MAIN 6 MAIN 1 IC3005(6/6) IC3005(1/6) R3183 OPEN R3416 OPEN R3185 OPEN H CN3006 29 28 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 TO MAIN CBA CN302 KEY-IN1 DIF-OUT2 GND DIF-OUT1 GND IF-AGC RESET SCL SDA AUDIO-MUTE COM-VIDEO-Pr-IN GND COM-VIDEO-Pb-IN GND COM-VIDEO-Y-IN GND AUDIO(L) INPUT0 AUDIO(R) INPUT1 GND S-VIDEO-Y-IN GND S-VIDEO-C-IN S-VIDEO-SW VIDEO-IN GND SPDIF GND CONTINUE DIGITAL 3 AUDIO(L) AUDIO(R) SPDIF CONTINUE DIGITAL 6 P-ON+5V(1) VGA-SDA VGA-SCL WP CONTINUE DIGITAL 6 HDMI-SDA HDMI-SCL CONTINUE DIGITAL 5 P-ON+5V AL+3.3V(2) P-ON+3.3V R3376 100 R3358 10K D3050 OPEN R3347 10K D3045 OPEN 11 6 1 R3356 75 D3049 OPEN 12 7 2 R3364 75 D3053 OPEN 13 8 3 R3377 75 D3055 OPEN 14 9 4 15 10 5 R3532 OPEN R3184 OPEN I J 10-22 JK3001 PC-RGB-IN CONTINUE DIGITAL 1 RESET-LCD R3186 OPEN G C3111 33P CONTINUE DIGITAL 3 KEY-IN1 LIGHT-SENS RESET 4 R3398 0 C3284 0.1 C3107 33P 2 R3284 47 NU B10 NU A11 NU D10 1 0.01 0.1 0.1 0.1 OPEN OPEN C3256 C3255 C3254 C3287 C3288 C3289 SW C10 C9 D8 B11 A10 C8 NU D9 C3198 C3199 C3200 C3201 C3202 C3290 C3105 OPEN C3112 R3181 OPEN 0 R3154 100 R3171 100 R3179 0 C3214 0.1 2 OPEN OPEN OPEN OPEN OPEN OPEN 2 C3291 OPEN C3292 OPEN C3293 OPEN R3296 100 R3298 100 C3194 0.1 C3195 0.1 C3196 0.1 VGA-HSYNC A14 VGA-VSYNC B14 A9 C7 C11 IC3013 SN74LVC1G126DCKR (BUFFER GATE) 1 VCC 5 CONTINUE DIGITAL 4 AUDIO-MUTE SDA SCL M32TD0 K L FL11.0SCDB2 Digital Main 3 Schematic Diagram [TYPE B] 1 NOTE: The order of pins shown in this diagram is different from that of actual IC3005. IC3005 is divided into six and shown as IC3005 (1/6) ~ IC3005 (6/6) in this Digital Main Schematic Diagram Section. DIGITAL MAIN CBA UNIT 4 CONTINUE DIGITAL 2 AUDIO(L) AUDIO(R) SPDIF R3335 100 R3336 100 C3338 OPEN R3500 OPEN C3341 OPEN C3227 OPEN C3229 OPEN R3503 OPEN R3504 OPEN R3501 OPEN R3502 OPEN CONTINUE DIGITAL 5 AUDIO(L)-OUT AUDIO(R)-OUT AMP(L)-OUT AMP(R)-OUT AL+3.3V R3499 OPEN R3518 OPEN R3520 OPEN R3322 0 R3325 0 C3337 OPEN C3340 OPEN C3223 10 C3224 10 *1 IC3005(3/6) R8A05011BG-U0 DIGITAL SIGNAL PROCESS /MAIN MICRO CONTROLLER 3 R3209 100 R3210 100 SPDIF N10 DTV-ON-H1 K16 P-ON-H2 B16 R3213 22 REMOTE C14 RESET-N J15 IC3009 PST8420UR (RESET) 1 GND OUT 4 R3178 10K R3517 100 VCOM-PWM F2 TO DIGITAL MAIN 2 IC3005(2/6) 2 AUDIO I/F TO DIGITAL MAIN 6 IC3005(6/6) KEY-IN1 LIGHT-SENS PROTECT1 PROTECT2 PROTECT3 DTV-ON-H2 LED-R R3313 R3315 R3316 R3312 R3314 R3514 R3215 A15 A13 C13 D13 B13 K14 F13 2 VDD 22 22 22 22 100 22 22 C3106 0.1 R3498 100K B6 A6 B7 A7 NU C5 C3120 0.01 C3113 0.033 CONTINUE DIGITAL 2 KEY-IN1 LIGHT-SENS RESET C3228 OPEN CONTINUE DIGITAL 5 P-ON+3.3V(2) CONTINUE DIGITAL 5 PROTECT1 PROTECT2 PROTECT3 DTV-ON-H2 DTV-ON-H1 LED-R P-ON-H2 REMOTE VCOM-PWM C3231 0.22 C3218 10 B8 M C3116 OPEN CD 3 CONTINUE DIGITAL 4 CPU-RESET-N C3217 10 LPF C12 NU D11 NU D7 NU C6 R3182 4.7K C3216 10 A8 1 C3252 0.1 R3191 100 R3340 10K C3219 10 C3220 10 N O P 10-23 Q R FL11.0SCDB3 Digital Main 4 Schematic Diagram [TYPE B] 1 NOTE: The order of pins shown in this diagram is different from that of actual IC3005. IC3005 is divided into six and shown as IC3005 (1/6) ~ IC3005 (6/6) in this Digital Main Schematic Diagram Section. 4 C3029 C3030 C3031 C3032 C3033 C3034 C3035 C3036 C3037 C3038 C3039 C3040 C3041 IC3002 K4T51163QI-HCF7 (DDR2 SDRAM) *A VDD 0.1 0.1 0.1 0.1 0.1 0.1 0.1 0.1 0.1 0.1 0.1 0.1 0.1 VREF J2 C3010 0.1 1-V3 2-V3 3-V3 SD-DQ15 SD-DQ14 SD-DQ13 SD-DQ12 SD-DQ11 SD-DQ10 SD-DQ9 SD-DQ8 3 4-V3 5-V3 6-V3 SD-DQ7 SD-DQ6 SD-DQ5 SD-DQ4 SD-DQ3 SD-DQ2 SD-DQ1 SD-DQ0 CKE CK CK CS RAS CAS WE BA2/NU BA1 BA0 A12 A11 A10/AP A9 A8 A7 A6 A5 A4 A3 A2 A1 A0 ODT K2 J8 K8 L8 K7 L7 K3 L1 L3 L2 R2 P7 M2 P3 P8 P2 N7 N3 N8 N2 M7 M3 M8 K9 NU NU NU NU NU B7 A8 B3 B9 B1 D9 D1 D3 D7 C2 C8 F7 E8 F3 F9 F1 H9 H1 H3 H7 G2 G8 UDQS UDQS/NU UDM DQ15 DQ14 DQ13 DQ12 DQ11 DQ10 DQ9 DQ8 LDQS LDQS/NU LDM DQ7 DQ6 DQ5 DQ4 DQ3 VSS *B DQ2 *A:A1,A9,C1,C3,C7,C9,E1,E9, G1,G3,G7,G9,J1,J9,M9,R1 DQ1 *B:A3,A7,B2,B8,D2,D8,E3,E7, DQ0 F2,F8,H2,H8,J3,J7,N1,P9 R3049 100 R3104 10K 1 CS VCC 8 2 SO NU 7 3 WP SCK 6 4 GND SI 5 C3051 0.1 M5 SD-VREF0 N3 GND R8 N8 P7 R6 P6 N7 T5 P8 P4 T3 R4 T2 P3 T4 R3 N4 T6 R5 T7 R7 N5 P5 3-S3 6-S3 2-S3 1-S3 5-S3 4-S3 R3024 R3015 R3016 R3048 R3035 R3036 R3037 R3038 R3039 R3040 R3041 R3042 R3043 R3044 R3045 R3046 R3047 R3032 R3033 R3034 R3102 10K L3004 BLM21PG221SN1D R3107 10K R3065 100 R3029 15 R3030 15 R3031 15 2 IC3006 MX25L3205DM2I-12G (MEMORY) C3050 0.1 SD-DQ15 SD-DQ14 SD-DQ13 SD-DQ12 SD-DQ11 SD-DQ10 SD-DQ9 SD-DQ8 SD-DQ7 SD-DQ6 SD-DQ5 SD-DQ4 SD-DQ3 SD-DQ2 SD-DQ1 SD-DQ0 C3009 0.1 E2 A2 R8 R7 R3 R3064 100 C3073 0.1 CN3007 1 2 3 4 5 6 7 8 9 10 R3451 11 OPEN 12 13 14 15 16 17 18 19 20 *1 IC3005(4/6) R8A05011BG-U0 DIGITAL SIGNAL PROCESS /MAIN MICRO CONTROLLER SD-DQ15 SD-DQ14 SD-DQ13 SD-DQ12 SD-DQ11 SD-DQ10 SD-DQ9 SD-DQ8 SD-DQ7 SD-DQ6 SD-DQ5 SD-DQ4 SD-DQ3 SD-DQ2 SD-DQ1 SD-DQ0 SD-UDM SD-LDM SD-UDQSN SD-UDQS SD-LDQSN SD-LDQS J3 SD-RAS H3 SD-CAS L4 SD-WE 6.8 6.8 15 15 15 15 15 15 15 15 15 15 15 15 15 15 15 15 15 15 R3070 150 R1 R2 L3 K2 M2 J2 J4 L2 H2 N1 K3 M1 H1 M3 K1 L1 J1 P1 K4 N2 H4 SD-CLKN SD-CLK SD-CKE SD-ODT SD-A12 SD-A11 SD-A10 SD-A9 SD-A8 SD-A7 SD-A6 SD-A5 SD-A4 SD-A3 SD-A2 SD-A1 SD-A0 SD-BA2 SD-BA1 SD-BA0 NU M32TRST-N G2 M32-TCK E1 R3224 10K ASEBRKAK-N ASEMD0 TRST-N TCK TDI TDO TMS F15 F16 E16 E15 D16 D15 E14 R3522 10K LED1 GND XIN25 XOUT25 CONTINUE DIGITAL 6 HDMI-SEL0 HDMI-SEL1 EDID-WPB R3516 100 BACKLIGHT-ADJ F3 R3515 22 J16 J14 H15 H16 C3184 18P X3001 25MHz C3183 18P R3223 1K AUDIO-MUTE G13 GPY10 E13 R3234 10K SOUT SIN SCK BACKLIGHT-SW P-ON-H1 R11 P11 T11 E2 C1 R3233 22 R3421 R3422 0 0 CN3010 1 2 3 4 R3395 OPEN TXD0 G15 R3468 0 RXD0 G16 R3469 0 CS P12 R3396 OPEN R3089 47 R3092 R3093 R3094 R3188 47 47 47 22 C3253 OPEN R3190 OPEN GPIO4 T9 GPIO5 R9 USBDP R10 USBDN T10 NU P10 NU H14 SCL R12 SDA T12 R3095 R3096 R3099 5.6K L3043 OPEN C3072 10 C3071 0.1 R3206 R3207 1 CN3009 1 2 3 4 C3246 1 L3025 EXC24CG900U D3052 OPEN C3348 100/16V C3327 0.1 22 22 R3480 10K S T CONTINUE DIGITAL 5 GPY10 P-ON-H1 LED1 BACKLIGHT-SW BACKLIGHT-ADJ CPU-RESET-N CONTINUE DIGITAL 5 P-ON+1.8V P-ON+3.3V AL+3.3V P-ON+5V CONTINUE DIGITAL 3 CPU-RESET-N CONTINUE DIGITAL 2 AUDIO-MUTE SDA SCL M32TD0 IC3019 BD2224G-TR (EEPROM) 1 VIN VOUT 5 2 GND 3 /EN /OC 4 (NO CONNECTION) P-ON+5V UART0-TX UART0-RX GND 22 0 R3479 10K (USB JACK) BUS-POWER USBDN USBDP GND (NO CONNECTION) P-ON+5V UART0-TX NU NU UART0-RX M32TDI AL+3.3V M32TDO M32TRST-N RESET-LCD GND M32TMS ASEBRKAK-N ASEMD0 TRST-N TCK TDI TDO TMS CPU-RESET-N L3041 BLM21PG221SN1D R3204 4.7K C3175 OPEN R3203 4.7K C3176 OPEN DIGITAL MAIN CBA UNIT U V 10-24 W X FL11.0SCDB4 Digital Main 5 Schematic Diagram [TYPE B] 1 NOTE: The order of pins shown in this diagram is different from that of actual IC3005. IC3005 is divided into six and shown as IC3005 (1/6) ~ IC3005 (6/6) in this Digital Main Schematic Diagram Section. R3068 R3058 R3083 DIGITAL MAIN CBA UNIT *1 IC3005(5/6) R8A05011BG-U0 DIGITAL SIGNAL PROCESS /MAIN MICRO CONTROLLER R3221 100 R3008 100 R3222 10K 3 C3181 0.1 VDD12 AVDD12 AVDD12 AVDD12 VCCQ33 VCCQ33 VCCQ33 VCCQ33 VCCQ33 AVDD33 *C J13 K6 M11 IC3004 BD7820FP-E2 (+1.8V REG.) S Q3013 SSM3K309T (SW+3.3V) L3015 BLM21PG221SN1D C3121 0.1 C3122 0.1 C3123 0.1 C3124 0.1 C3125 0.1 C3127 0.1 C3128 0.1 C3129 0.1 C3133 10 C3134 OPEN C3157 0.1 C3158 0.1 C3159 0.1 2 3 4 5 C3023 10 C3108 100/16V C3027 0.1 C3024 10 L3016 BLM21PG221SN1D F5 G4 J12 K13 L12 N11 R3009 100 1 C3004 1000P L3001 2.2uH C3126 0.1 CONTINUE DIGITAL 4 P-ON+1.8V P-ON+3.3V AL+3.3V P-ON+5V CONTINUE DIGITAL 2 P-ON+5V AL+3.3V(2) P-ON+3.3V CONTINUE DIGITAL 6 P-ON+3.3V AL+3.3V(2) R3061 1K R3060 470 R3059 150 C3049 100/4V C3263 1 Q3003 2SC4081UBTLQ (SWITCHING) Q3004 R3079 2SC4081UBTLQ 10K (SWITCHING) C3054 1 R3086 2.2K R3077 10K R3084 2.2K IC3007 BD7820FP-E2 (+1.8V REG.) C3322 10 C3321 10 C3320 10 C3319 10 C3318 10 C3114 10 C3140 0.1 C3141 0.1 C3142 0.1 C3143 0.1 C3144 0.1 C3145 0.1 R3525 OPEN C C3343 10 OUT C3325 C3324 10 10 GND C3079 100/4V C3264 0.01 C3326 10 VCC H5 J5 M4 M6 M7 M8 N6 T1 1 2 3 4 5 C3068 10 C3069 10 R3110 1.2K R3109 270 C3070 0.1 R3111 C3075 OPEN 1K C3135 0.1 AVDD12 AVDD12 AVDD12 AVDD33 AVDD33 AVDD33 AVDD33 E8 F8 F9 E10 C2 C3 E11 C3346 10 BC3001 C3066 220/6.3V 2.2uH C3347 10 C3147 0.1 C3148 0.1 C3149 0.1 C3150 10 C3151 0.1 C3091 1000P C3139 0.1 1 R3141 10 CONTINUE DIGITAL 3 P-ON+3.3V(2) C3085 0.1 R3100 22K Q3005 2SC4081UBTLQ IC3008 (SWITCHING) BD9321EFJ-E2 (DC-DC CONVERTER) C3083 0.01 1 BST SS 8 3 SW R3106 R3105 22K 1K Q3006 2SA1774TLQ (SWITCHING) C3015 10 C3016 0.1 R3054 0 C3019 10 C3022 0.1 C3028 10 C3043 0.1 R3066 OPEN C3046 1000P C3045 10 C3047 0.1 C3094 47/4V C3062 1000P C3067 1000P R3133 10K R3137 6.8K C3088 0.015 C3097 10 C3096 10 R3149 0 R3087 R3085 R3078 R3074 D3002 OPEN R3145 6.04K C3057 1000P R3143 15K Y Z BB AA 10-25 C3055 1000P C3048 OPEN R3464 OPEN R3101 100 C3090 1 FB 5 C3044 1000P R3072 100 D3101 1SS400TE61 D3102 1SS400TE61 COMP 6 4 GND D3001 SK22A R3050 0 EN 7 L3009 10uH CONTINUE DIGITAL 6 P-ON+3.3V(2) C3008 100P R3073 0 L3044 BLM21PG221SN1D 2 VIN C3011 0 D3104 1SS400TE61 Q3101 2SC4081UBTLQ (SWITCHING) C3265 10 R3097 2.2K L3028 BLM21PG221SN1D *C:G5,G6,H6,J7,J11,K7,K11,L8, L9,M9,N9,P9 *D:F4,F6,F7,F10,F11,G7,H7~H12, J6,J8~J10,K5,K8~K10,K12, L5~L7,L11,P2,T8 C3077 100/16V C3006 1000P R3531 OPEN D3103 1SS400TE61 L3003 BLM21PG221SN1D R3423 47K C3152 0.1 VDDCLK G11 C3053 0.1 R3424 100 D3106 1SS400TE61 C3081 C3080 10 10 C3082 0.1 D3105 1SS400TE61 L3026 BLM21PG221SN1D ADAC D6 AADC E6 C3052 10 L3021 BLM21PG221SN1D C3136 0.1 L3019 BLM21PG221SN1D C3117 10 C3076 10 C3005 1000P R3014 100 R3062 22K L3020 BLM21PG221SN1D AVDD12 M10 R3526 OPEN R3011 100 C3060 220/6.3V 2 CONTINUE DIGITAL 1 OE2 LCD+12V R3017 OPEN L3014 BLM21PG221SN1D CTL VCCQ18 VCCQ18 VCCQ18 VCCQ18 VCCQ18 VCCQ18 VCCQ18 VCCQ18 CONTINUE DIGITAL 4 GPY10 P-ON-H1 LED1 BACKLIGHT-SW BACKLIGHT-ADJ CPU-RESET-N R3010 100 C D OUT AVSS12 AVSS12 AVSS12 AVSS12 AVSS12 AVSS33 AVSS33 AVSS33 AVSS33 AVSS33 AVSS33 PD1 PD1 PD1 PD1 G C3182 0.1 GND H13 L10 G10 G8 G9 E9 D2 D3 D12 D5 E7 E3 E4 D4 E5 C3160 0.1 C3003 100P VCC *D VSS VCC33STB F12 VCC33STB G12 VDDSTB E12 L3027 BLM21PG221SN1D CTL 4 CONTINUE DIGITAL 3 PROTECT1 PROTECT2 PROTECT3 DTV-ON-H2 DTV-ON-H1 LED-R P-ON-H2 REMOTE VCOM-PWM 100 100 100 C3061 1000P CC C3063 0 OPEN OPEN 100 100 R3524 OPEN CN3002 29 28 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 TO MAIN CBA CN301 VCOM-PWM BACKLIGHT-ADJ LED1 BACKLIGHT-SW REMOTE OE2 GND AL+3.3V AL+3.3V P-ON+3.3V P-ON+3.3V GND GND P-ON+7V PROTECT2 P-ON+5V LED-R GND PROTECT1 P-ON+3V P-ON-H1 AMP(R)-OUT GND AMP(L)-OUT PROTECT3 AUDIO(R)-OUT(NU) GND AUDIO(L)-OUT(NU) P-ON-H2 CONTINUE DIGITAL 1 P-ON+3.3V CONTINUE DIGITAL 3 AUDIO(L)-OUT AUDIO(R)-OUT AMP(L)-OUT AMP(R)-OUT AL+3.3V C3065 0 DD FL11.0SCDB5 Digital Main 6 Schematic Diagram [TYPE B] 1 NOTE: The order of pins shown in this diagram is different from that of actual IC3005. IC3005 is divided into six and shown as IC3005 (1/6) ~ IC3005 (6/6) in this Digital Main Schematic Diagram Section. CONTINUE DIGITAL 5 P-ON+3.3V AL+3.3V(2) L3046 BLM21PG221SN1D C3311 0.01 C3312 0.1 C3313 0.01 C3331 0.1 C3332 0.01 C3333 0.1 C3334 0.01 AUDIO DECODER C3302 0.1 C3303 0.01 C3304 0.1 C3305 0.01 C3306 0.1 C3307 0.01 C3308 0.1 C3309 0.01 R3405 100 R3415 82K D3057 RB751S-40TE61 HDMI-CEC B15 R3486 4.64K R3237 27K 16 15 14 13 12 11 10 8 9 7 6 5 4 3 18 HDMI I/F 3 R3489 10K R3412 OPEN 62 R3408 OPEN 20 VCC 61 21 60 HDMI SW 24 R3481 0 R3482 0 53 29 SCL-SINK 52 30 SDA-SINK HDMI-SEL1 F1 R3497 4.7K 33 34 HOT-PULG- 50 DETECT2 NU 49 35 36 37 38 39 40 41 42 43 R3274 47K 44 45 46 R3277 R3389 47K 0 R3374 1K C3260 R3409 1 2.7K VCC R3496 4.7K R3386 OPEN 51 31 HOT-PULGDETECT-SINK 32 HDMISEL0 GND R3508 22 R3509 22 54 28 GND VCC HDMI-SEL0 G3 27 HOT-PULGDETECT1 HDMI1-HPD D14 VCC 55 HDMISEL1 NU HDMI1-SDA C15 D3067 OPEN 56 26 48 47 EXT-RES C4 PLL-XFC-A B5 PLL-XFC-P A5 2 R3385 10K C3186 4700P R3271 C3188 3K 2200P R3236 560 C3185 0.01 PWR M12 R3477 OPEN R3478 OPEN CONTINUE DIGITAL 5 P-ON+3.3V(2) 1 R3512 OPEN R3293 10K CONTINUE DIGITAL 4 HDMI-SEL0 HDMI-SEL1 EDID-WPB R3453 OPEN R3452 OPEN R3510 22 R3456 OPEN CONTINUE DIGITAL 2 HDMI-SDA HDMI-SCL 1 VCC1 VCC2 16 2 SCL1 SCL2 15 3 SDA1 SDA2 14 4 WPB R3455 OPEN Q3034 OPEN R3523 10K C3192 0.1 R3282 100 R3281 100 5 VCC-OUT FF SDA3 11 SCL3 10 8 VCC0 VCC3 9 JK3003 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 HDMICONNECTOR-1 TMDS-D2(+) D-SHIELD0 TMDS-D2(-) TMDS-D1(+) D-SHIELD1 TMDS-D1(-) TMDS-D0(+) D-SHIELD2 TMDS-D0(-) TMDS-CLOCK(+) C-SHIELD0 TMDS-CLOCK(-) HDMI-CEC NU HDMI-CLOCK HDMI-DATA GND +5V HOT PLUG DETECT C3261 R3410 2.7K 1 R3407 1K R3372 1K R3373 OPEN Q3031 2SC4081UBTLQ (SWITCHING) R3383 10K C3212 0.1 HH 10-26 R3388 0 R3413 OPEN C3190 0.1 GND 12 7 SCL0 GG R3301 10K R3276 47K CONTINUE DIGITAL 2 P-ON+5V(1) VGA-SDA VGA-SCL WP NU 13 6 SDA0 C3191 0.1 EE C3213 0.1 IC3011 BU9883FV-WE2 (HDMI SERIAL EEPROM) R3273 D3066 1SS400TE61 47K Q3024 2SK3018T106 (BUFFER) HDMICONNECTOR-2 TMDS-D2(+) D-SHIELD0 TMDS-D2(-) TMDS-D1(+) D-SHIELD1 TMDS-D1(-) TMDS-D0(+) D-SHIELD2 TMDS-D0(-) TMDS-CLOCK(+) C-SHIELD0 TMDS-CLOCK(-) HDMI-CEC NU HDMI-CLOCK HDMI-DATA GND +5V HOT PLUG DETECT Q3032 2SC4081UBTLQ (SWITCHING) R3406 1K D3065 1SS400TE61 JK3004 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 R3375 OPEN R3414 OPEN R3270 C3187 2.2K 2.2 (NO CONNECTION) TMDS-D2(+) D-SHIELD0 TMDS-D2(-) TMDS-D1(+) D-SHIELD1 TMDS-D1(-) TMDS-D0(+) D-SHIELD2 TMDS-D0(-) TMDS-CLOCK(+) C-SHIELD0 TMDS-CLOCK(-) HDMI-CEC NU HDMI-CLOCK HDMI-DATA GND +5V HOT PLUG DETECT Q3030 OPEN 57 25 VCC JK3002 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 R3371 OPEN GND 58 23 HDMI1-SCL C16 R3370 OPEN 59 22 GND R3487 4.7K R3278 R3387 OPEN OPEN HOT-PULG- 64 DETECT3 63 19 VCC R3488 4.7K R3275 OPEN C3262 R3411 OPEN OPEN 17 B1 A1 B2 A2 B3 A3 B4 A4 IC3018 BU16027KV (HDMI SW) 1 2 GND VIDEO DECODER C3301 0.01 VCC TO DIGITAL MAIN 3 IC3005(3/6) C3300 0.1 GND TO DIGITAL MAIN 2 IC3005(2/6) Q3014 2SK3018T106 (BUFFER) C3315 0.01 VCC *1 IC3005(6/6) R8A05011BG-U0 DIGITAL SIGNAL PROCESS /MAIN MICRO CONTROLLER C3314 0.1 NU 4 C3310 0.1 GND C3316 10 R3507 0 R3476 0 R3475 0 DIGITAL MAIN CBA UNIT II JJ FL11.0SCDB6 Digital Main 1 Schematic Diagram [TYPE C] 1 NOTE: The order of pins shown in this diagram is different from that of actual IC3005. IC3005 is divided into five and shown as IC3005 (1/5) ~ IC3005 (5/5) in this Digital Main Schematic Diagram Section. CONTINUE DIGITAL 4 VCOM-PWM 4 3 (NO CONNECTION) CN3011 LCD+5V 31 LCD+5V 30 LCD+5V 29 GND 28 VCOM-PWM 27 PWR-CTRL 26 LCD+5V 25 GND 24 NU 23 NU 22 D0(-) 21 D0(+) 20 D1(-) 19 D1(+) 18 GND 17 D2(-) 16 D2(+) 15 GND 14 CK(-) 13 CK(+) 12 D3(-) 11 D3(+) 10 NU 9 NU 8 GND 7 GND 6 GND 5 GND 4 NU 3 NU 2 NU 1 2 R3026 0 R3045 22K R3047 1K R3044 15K R3048 1K R3046 11K C3058 0.1 R3021 OPEN Q3002 OPEN C3054 OPEN R3034 OPEN D3004 OPEN C3057 47/25V R3023 OPEN Q3007 2SC4081UBTLQ (V-COM DRIVE) C3019 OPEN R3022 OPEN Q3001 OPEN R3025 0 1 8 2 7 3 6 4 5 C3047 100/35V CONTINUE DIGITAL 4 P-ON+5V P-ON+21V P-ON+3.3V R3027 OPEN C3061 1 C3045 1000P R3038 OPEN R3039 OPEN R3035 0 R3028 0 *1 IC3005(1/5) R8A05011BG-U0 DIGITAL SIGNAL PROCESS /MAIN MICRO CONTROLLER LVDS TX R16 R15 P14 P13 N16 N15 P16 P15 T16 T15 R14 T14 R13 T13 C3352 OPEN C3349 OPEN C3350 OPEN C3351 OPEN C3353 OPEN C3354 OPEN C3355 OPEN TO DIGITAL MAIN 2 IC3005(2/5) R3152 1K OPEN OPEN OPEN OPEN OPEN OPEN 1 L13 M15 L16 L15 M14 L14 M16 M13 N14 N13 K15 R3511 22 C3161 C3162 C3163 C3164 C3165 R3041 TP POL CPV OE STV NU NU NU CELL-PWR-CTRL NU NU R3088 7.5K R3037 OPEN CN3006 30 29 28 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 TO LCD MODULE ASSEMBLY LCD+21V LCD+21V GND VCOM-PWM PWR-CTRL P-ON+3.3V GND LLV0(+) LLV0(-) LLV1(+) LLV1(-) LLV2(+) LLV2(-) GND LLVCNK(+) LLVCLK(-) GND LLV3(+) LLV3(-) LLV4(+) LLV4(-) LLV5(+) LLV5(-) GND TP POL CPV OE1 XA0 STV CN3005 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 (NO CONNECTION) GND LLV0(+) LLV0(-) LLV1(+) LLV1(-) LLV2(+) LLV2(-) GND LLVCNK(+) LLVCLK(-) GND LLV3(+) LLV3(-) LLV4(+) LLV4(-) LLV5(+) LLV5(-) GND TP POL CPV OE1 XA0 STV R3036 OPEN DIGITAL MAIN CBA UNIT A B C D 10-27 E F FL11.0SCDC1 Digital Main 2 Schematic Diagram [TYPE C] 1 NOTE: The order of pins shown in this diagram is different from that of actual IC3005. IC3005 is divided into five and shown as IC3005 (1/5) ~ IC3005 (5/5) in this Digital Main Schematic Diagram Section. 4 3 4 6 D3405 OPEN C3402 0.1 C3403 0.1 C3410 10P C3407 0.1 L3401 2.2uH C3401 10 R3407 OPEN R3418 0 D3403 EDZTE615.6B C3411 10P *1 IC3005(2/5) R8A05011BG-U0 DIGITAL SIGNAL PROCESS /MAIN MICRO CONTROLLER 3 C3406 33P C3409 0.1 C3404 100P IC3012 AT24C02BN-SH-T (MEMORY) C3175 OPEN C3176 OPEN R3204 4.7K 2 D3402 EDZTE615.6B C3405 33P R3203 4.7K 3 GND D3404 EDZTE615.6B R3338 0 DEMODULATOR /MPEG DECODER A12 IF-AGC A16 NU D1 R3354 0 C3226 OPEN C3225 OPEN R3337 0 R3202 2.7K R3205 18K R3353 0 R3194 0 C3178 0.1 Q3012 2SK3018T106 (BUFFER) R3296 100 1 A0 VCC 8 2 A1 WP 7 3 A2 SCL 6 4 GND SDA 5 C3211 0.1 R3310 10K Q3034 2SC4081UBTLQ (SWITCHING) R3361 OPEN R3360 OPEN R3339 100 2 C3198 C3199 C3200 C3201 R3286 0 0.01 0.1 0.1 0.1 R3321 4.7K D3041 OPEN D3054 OPEN R3358 10K D3050 OPEN R3347 10K D3045 OPEN R3356 OPEN D3049 OPEN R3364 OPEN D3053 OPEN R3377 OPEN D3055 OPEN R3402 0 R3192 4.7K R3401 0 R3193 4.7K Q3702 OPEN VGA-SCL G14 VGA-SDA F14 NU B10 NU A11 NU D10 C3197 0.1 C3335 2.2 OUT C JK3001(REAR) PC-RGB-IN WF1 R3403 0 DIGITAL SIGNAL PROCESS TO DIGITAL TO DIGITAL MAIN 1 MAIN 5 IC3005(5/5) IC3005(1/5) CONTINUE DIGITAL 4 P-ON+3.3V P-ON+5V PROTECT1 P-ON-H1 11 6 1 12 7 2 13 8 3 14 9 4 15 10 5 CONTINUE DIGITAL 3 EDID-WPB COMP-DET R3291 75 R3292 75 R3293 75 NU NU NU NU R3285 0 56P 56P 56P OPEN OPEN OPEN A/D CONVERTER C10 C9 D8 B11 A10 C8 D9 B9 R3326 4.7K D3040 1SS400TE61 R3376 100 R3343 100 C3194 0.1 C3195 0.1 C3196 0.1 C3287 C3288 C3289 C3291 C3292 C3293 SW R3413 OPEN C3412 OPEN R3456 4.7K R3455 4.7K R3284 0 VGA-HSYNC A14 VGA-VSYNC B14 A9 C7 C11 R3411 OPEN R3412 OPEN D3027 1SS400TE61 L3023 C3242 R3368 OPEN OPEN OPEN C3177 OPEN 5 R3410 OPEN C3235 OPEN L3022 OPEN 4 4 R3298 100 R3206 22 R3207 22 3 C3413 OPEN Q3011 2SK3018T106 (BUFFER) R3369 L3024 C3243 OPEN OPEN OPEN SCL R12 SDA T12 B12 TO DIGITAL MAIN 5 IC3005(5/5) R3417 OPEN 2 4 IC3014 74LVC1G126GW (BUFFER GATE) 1 VCC 5 R3414 0 1 C3214 0.1 3 GND C3408 D3401 100/6.3V EDZTE615.6B GND 7 2 VCC DIF-OUT1 IF-AGC 5 DIF-OUT2 2 SCL SDA GND +3.3V 1 IC3013 74LVC1G126GW (BUFFER GATE) 1 VCC 5 CTL IC3401 OPEN TU3401 TUNER UNIT C3272 OPEN C3271 OPEN R3706 18K R3719 0 C3285 0.1 C3286 0.1 C3336 1 C3710 OPEN R3717 OPEN R3714 OPEN R3707 18K C3701 39P R3701 75 C3702 39P R3702 75 C3703 39P R3703 75 C3704 1 R3704 100K C3705 1 R3705 100K JK3701(REAR) COMPONENT-Y /VIDEO-IN WF2 COMPONENT -Pb-IN WF3 COMPONENT -Pr-IN WF4 AUDIO(L)-IN AUDIO(R)-IN Q3703 OPEN C3708 0.1 1 9.2 3.8 JK3702(REAR) DIGITAL AUDIO-OUT (COAXIAL) G R3709 220 C3706 1 C3709 100P C3713 R3715 OPEN OPEN R3711 10K C3712 R3713 OPEN OPEN R3710 C3707 0 1 4.3 Q3701 R3712 2SC4081UBTLQ 10K (BUFFER) R3708 110 R3720 0 C3711 OPEN CONTINUE DIGITAL 5 AUDIO(L)-IN AUDIO(R)-IN R3716 OPEN R3718 OPEN CONTINUE DIGITAL 5 SPDIF DIGITAL MAIN CBA UNIT H I J 10-28 K L FL11.0SCDC2 Digital Main 3 Schematic Diagram [TYPE C] 1 NOTE: The order of pins shown in this diagram is different from that of actual IC3005. IC3005 is divided into five and shown as IC3005 (1/5) ~ IC3005 (5/5) in this Digital Main Schematic Diagram Section. *1 IC3005(3/5) R8A05011BG-U0 DIGITAL SIGNAL PROCESS /MAIN MICRO CONTROLLER C3009 0.1 R3064 100 R3065 100 4 OPEN 0.1 OPEN 0.1 OPEN 0.1 OPEN 0.1 OPEN 0.1 OPEN 0.1 OPEN *A VDD VREF J2 C3010 0.1 1-O3 2-O3 3-O3 SD-DQ15 SD-DQ14 SD-DQ13 SD-DQ12 SD-DQ11 SD-DQ10 SD-DQ9 SD-DQ8 3 4-O3 5-03 6-O3 SD-DQ7 SD-DQ6 SD-DQ5 SD-DQ4 SD-DQ3 SD-DQ2 SD-DQ1 SD-DQ0 CKE CK CK CS RAS CAS WE BA2/NU BA1 BA0 A12 A11 A10/AP A9 A8 A7 A6 A5 A4 A3 A2 A1 A0 ODT K2 J8 K8 L8 K7 L7 K3 L1 L3 L2 R2 P7 M2 P3 P8 P2 N7 N3 N8 N2 M7 M3 M8 K9 E2 A2 R8 R7 R3 NU NU NU NU NU B7 A8 B3 B9 D7 D3 D9 D1 B1 C2 C8 F7 E8 F3 F9 F1 H9 H1 H3 H7 G2 G8 UDQS UDQS/NU UDM DQ15 DQ14 DQ13 DQ12 DQ11 DQ10 DQ9 DQ8 LDQS LDQS/NU LDM DQ7 DQ6 DQ5 DQ4 DQ3 VSS *B DQ2 *A:A1,A9,C1,C3,C7,C9,E1,E9, G1,G3,G7,G9,J1,J9,M9,R1 DQ1 DQ0 *B:A3,A7,B2,B8,D2,D8,E3,E7, F2,F8,H2,H8,J3,J7,N1,P9 R3049 100 1 CS VCC 8 2 SO NU 7 3 WP SCK 6 4 GND SI 5 R3031 1 CN3009 1 2 3 4 C3246 1 D3052 OPEN 15 6.8 6.8 15 15 15 15 150 15x4 15x4 R3032 15x4 R3033 15x4 R3102 10K R3107 10K R3089 R3092 R3093 R3094 R3095 R3096 47 47 47 47 22 0 C3348 100/16V R3099 5.6K IC3019 BD2224G-TR (HIGH SIDE SW) 1 VIN VOUT 5 L3025 EXC24CG900U C3327 0.1 M5 SD-VREF0 N3 GND C3184 16P XIN25 H15 XOUT25 H16 R3223 1K R8 N8 P7 R6 P6 N7 T5 P8 P4 T3 R4 T2 P3 T4 R3 N4 T6 R5 T7 R7 N5 P5 SD-DQ15 SD-DQ14 SD-DQ13 SD-DQ12 SD-DQ11 SD-DQ10 SD-DQ9 SD-DQ8 SD-DQ7 SD-DQ6 SD-DQ5 SD-DQ4 SD-DQ3 SD-DQ2 SD-DQ1 SD-DQ0 SD-UDM SD-LDM SD-UDQSN SD-UDQS SD-LDQSN SD-LDQS L4 R1 R2 L3 H2 H1 N2 H4 M2 N1 M3 P1 K2 L2 M1 L1 J2 K3 K1 J1 J3 H3 J4 K4 SD-WE SD-CLKN SD-CLK SD-CKE SD-A8 SD-A4 SD-BA0 NU SD-A12 SD-A7 SD-A3 SD-BA2 SD-ODT SD-A9 SD-A5 SD-A1 SD-A11 SD-A6 SD-A2 SD-A0 SD-RAS SD-CAS SD-A10 SD-BA1 P12 R11 P11 T11 T9 R9 R10 T10 P10 CS SOUT SIN SCK EN OC USBDP USBDN NU ASEBRKAK-N ASEMD0 TRST-N TCK TDI TDO TMS X3001 25MHz C3183 16P F15 F16 E16 E15 D16 D15 E14 R3522 10K R3395 4.7K TXD0 RXD0 NU NU NU EDIO-WPB NU BACKLIGHT-ADJ VCOM-PWM GND G15 G16 G1 F1 G2 E1 G3 F3 F2 J14 R3468 100 R3469 100 R3396 4.7K B16 K14 K16 C1 BACKLIGHT-SW E2 R3516 100 R3517 100 COMP-DET N12 CN3010 1 2 3 C3253 4 OPEN (NO CONNECTION) P-ON+5V UART0-TX UART0-RX GND CONTINUE DIGITAL 5 CPU-RESET-N CONTINUE DIGITAL 4 GPY10 CPU-RESET-N P-ON-H2 DTV-ON-H2 DTV-ON-H1 P-ON-H1 BACKLIGHT-ADJ BACKLIGHT-SW VCOM-PWM R3211 R3514 R3210 100 100 100 R3188 22 R3503 10K LED1 J16 AUDIO-MUTE G13 REMOTE C14 (NO CONNECTION) AL+3.3V GND ASEBRKAK-N ASEMD0 TRST-N TCK TDI TDO TMS CPU-RESET-N CONTINUE DIGITAL 2 EDID-WPB COMP-DET R3510 22 NU F13 GPY10 E13 P-ON-H2 DTV-ON-H2 DTV-ON-H1 P-ON-H1 CN3012 1 2 3 4 5 6 7 8 9 10 CONTINUE DIGITAL 5 LED1 AUDIO-MUTE REMOTE R3515 4.7K R3233 22 R3213 22 R3234 10K R3215 R3201 33K 22 CONTINUE DIGITAL 4 P-ON+1.8V P-ON+3.3V AL+3.3V P-ON+5V C3073 0.1 R3479 10K (USB JACK) BUS-POWER USBDN USBDP GND 3-M3 6-M3 2-M3 1-M3 5-M3 4-M3 R3050 R3024 R3015 R3016 R3040 R3029 R3020 R3070 R3030 2 IC3006 W25Q32BVSSIG (MEMORY) C3051 0.1 SD-DQ15 SD-DQ14 SD-DQ13 SD-DQ12 SD-DQ11 SD-DQ10 SD-DQ9 SD-DQ8 SD-DQ7 SD-DQ6 SD-DQ5 SD-DQ4 SD-DQ3 SD-DQ2 SD-DQ1 SD-DQ0 IC3002 K4T51163QI-HCF7 (DDR2 SDRAM) C3029 C3030 C3031 C3032 C3033 C3034 C3035 C3036 C3037 C3038 C3039 C3040 C3041 C3050 0.1 NU H14 C3072 10 C3071 0.1 2 GND 3 /EN /OC 4 L3041 220uH R3480 10K DIGITAL MAIN CBA UNIT M N O P 10-29 Q R FL11.0SCDC3 Digital Main 4 Schematic Diagram [TYPE C] 1 NOTE: The order of pins shown in this diagram is different from that of actual IC3005. IC3005 is divided into five and shown as IC3005 (1/5) ~ IC3005 (5/5) in this Digital Main Schematic Diagram Section. DIGITAL MAIN CBA UNIT C3125 OPEN C3126 0.1 C3127 OPEN C3128 0.1 C3129 OPEN C3134 C3132 10 10 L3020 220uH C3133 10 L3001 2.2uH R3084 2.2K C3155 1 C3076 BC3001 2.2uH 10 C3139 0.1 C3325 10 C3324 OPEN C3343 10 C3264 0.01 C3322 OPEN C3321 10 C3320 OPEN C3319 10 C3114 OPEN C3318 10 C3140 OPEN C3141 0.1 C3142 OPEN C3143 0.1 C3144 OPEN C3145 0.1 C3081 1 C3082 0.1 L3019 220uH C3149 0.1 C3150 0.1 C3091 1000P C3117 0.1 L3026 220uH R3141 10 C3085 0.1 L3029 C3154 BEAD 0.1 VCCQ33 VCCQ33 VCCQ33 VCCQ33 VCCQ33 AVDD33 G4 F5 L12 K13 J12 N11 C3152 0.1 C3158 OPEN EN 7 COMP 6 FB 5 R3134 10K R3137 6.8K C3159 0.1 C3089 D3001 OPEN OPEN R3051 OPEN C3168 OPEN C3012 0.1 C3094 330/4V C3067 330/4V C3097 10 C3096 10 C3007 1 C3092 1000P R3052 10 C3090 1 C3049 100/4V C3131 1 C3066 100/16V 2 VIN C3014 0.1 3 SW C3068 OPEN 4 GND C3064 10 C3065 10 C3093 D3002 OPEN OPEN R3053 OPEN D3006 EDZTE615.6B C3026 0.1 C3025 1 C3095 1000P *C:G5,G6,H6,J7,J11,J13,K6,K7, K11,L8,L9,M9,N9,P9,M11. *D:D2~D5,D12,E3~E5,E7,E9,F4,F6, F7,F10,F11,G7~G10,H7~H13,J6, J8~10,K5,K8~K10,K12,L5~L7, L10,L11,P2,T8 R3054 10 C3042 0.1 C3022 IC3003 4.7 MP2303ADNLFZ (DC-DC CONVERTER) C3028 0.1 1 BST SS 8 2 VIN 3 SW 4 GND 1 C3170 OPEN 5 C3070 0.1 R3110 1.1K R3109 390 C3079 100/4V C3087 10 C3167 OPEN R3111 C3075 1K OPEN C3001 100/35V C3109 10 C3110 10 C3111 10 C3112 10 L3013 0 C3020A OPEN C3101 C3021 10 10 R3004 15K R3003 6.8K C3062 10 C3063 10 D3005 EDZTE615.6B 1 2 3 4 5 C3146 0.1 C3138 1 C3153 1 C3011 1 C3046 1 C3052 1 COMP 6 R3005 3.3K FB 5 R3072 100 C3074 10 C3056 10 R3012 15K R3007 10K C3601 0.1 C3602 100/4V C3603 1 C3015 10 C3016 0.1 C3044 0.1 C3104 10 D3007 EDZTE616.8B R3006 4.7K S T CONTINUE DIGITAL 3 GPY10 CPU-RESET-N P-ON-H2 DTV-ON-H2 DTV-ON-H1 P-ON-H1 BACKLIGHT-ADJ BACKLIGHT-SW VCOM-PWM C3017 0.015 C3020 220/6.3V U V 10-30 CONTINUE DIGITAL 5 RESET PROTECT1 PROTECT3 CONTINUE DIGITAL 5 AL+3.3V P-ON+5V P-ON+3.3V(1) AMP+11V IC3601 AP2121AK-3.3TRE1 (+3.3V REG.) C3171 OPEN C3043 0.015 C3053 220/6.3V 4 R3001 6.8K FB 5 CONTINUE DIGITAL 1 P-ON+5V P-ON+21V P-ON+3.3V R3002 6.8K R3042 10K EN 7 L3005 22uH C3098 D3003 OPEN OPEN R3055 OPEN C3105 4.7 C3086 10 3 C3069 10 R3143 15K VSS *D C3263 1 2 C3018 1 L3002 22uH R3149 100 R3145 8.2K R3061 1K 1 EN 7 COMP 6 R3060 470 R3059 180 IC3007 BD7820FP-E2 (+1.8V REG.) C3166 C3002 C3102 OPEN 4.7 4.7 IC3001 MP2303ADNLFZ (DC-DC CONVERTER) C3013 0.1 R3010 SS 8 1 BST 10K R3133 10K C3088 0.015 L3009 22uH L3016 220uH C3157 0.1 3 SW 4 GND AVDD33 E6 C3151 0.1 2 VIN C3169 OPEN VOUT C3148 0.1 C3103 4.7 NU C3147 1 C3080 4.7 IC3008 MP2303ADNLFZ (DC-DC CONVERTER) C3083 0.015 SS 8 1 BST CE E10 C2 C3 E11 D6 C3326 OPEN GND 2 AVDD33 AVDD33 AVDD33 AVDD33 AVDD33 H5 J5 M4 T1 M6 N6 M7 M8 L3014 220uH VIN VCCQ18 VCCQ18 VCCQ18 VCCQ18 VCCQ18 VCCQ18 VCCQ18 VCCQ18 C3027 0.1 Q3004 2SC4081UBTLQ (SWITCHING) L3028 220uH VDDCLK G11 5 C3024 10 Q3003 2SC4081UBTLQ (SWITCHING) R3079 10K C3156 1 4 R3086 2.2K R3077 10K L3021 220uH C3137 1 C3023 OPEN C3108 100/16V 3 C3055 C3060 C3059 C3048 C3005 C3004 C3006 C3003 C3136 0.1 D3104 1SS400TE61 D3106 1SS400TE61 D3101 1SS400TE61 D3102 1SS400TE61 2 6.8K 100 100 100 100 100 100 C3124 0.1 1 R3019 R3018 R3068 R3013 R3009 R3011 R3008 C3123 0.1 R3097 2.2K Q3005 2SC4081UBTLQ (SWITCHING) CONTINUE DIGITAL 2 P-ON+3.3V P-ON+5V PROTECT1 P-ON-H1 1000P 1000P 1000P OPEN 100P 1000P 1000P 100P C3122 OPEN R3423 47K IC3004 BD7820FP-E2 (+1.2V REG.) R3424 100 C3265 D3103 1SS400TE61 10 C C3121 OPEN Q3101 2SC4081UBTLQ (SWITCHING) C R3105 Q3006 2SA1576UBTLQ 1K (SWITCHING) L3015 220uH C3135 0.1 D3105 OPEN OUT Q3013 SSM3K309T (SW+12V) AVDD12 M10 R3100 22K R3464 OPEN OUT R3106 22K S GND D VDD12 *C AVDD12 E8 AVDD12 F8 AVDD12 F9 L3027 220uH G GND C3182 0.1 VCC C3160 0.1 VCC R3222 10K R3220 0 CTL VCC33STB F12 VCC33STB G12 VDD12STB E12 L3030 BEAD C3181 0.1 3 CONTINUE DIGITAL 3 P-ON+1.8V P-ON+3.3V AL+3.3V P-ON+5V R3221 100 CTL 4 *1 IC3005(4/5) R8A05011BG-U0 DIGITAL SIGNAL PROCESS /MAIN MICRO CONTROLLER W CONTINUE DIGITAL 1 VCOM-PWM CN3701 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 TO MAIN CBA CN601 VCOM-PWM(NU) BACKLIGHT-SW BACKLIGHT-ADJ PROTECT3 PROTECT1 P-ON-H1(NU) P-ON-H2 RESET GND GND AL+5V GND AMP+11V AMP+11V GND P-ON+21V P-ON+21V GND GND X FL11.0SCDC4 Digital Main 5 Schematic Diagram [TYPE C] 1 NOTE: The order of pins shown in this diagram is different from that of actual IC3005. IC3005 is divided into five and shown as IC3005 (1/5) ~ IC3005 (5/5) in this Digital Main Schematic Diagram Section. VIDEO SIGNAL CONTINUE DIGITAL 4 AL+3.3V P-ON+5V P-ON+3.3V(1) AMP+11V R3183 100 C3557 OPEN C3558 10 CONTINUE DIGITAL 3 R3185 10K LED1 AUDIO-MUTE REMOTE R3236 560 CN3102 1 2 3 4 5 6 7 R3552 100 C3553 100P TO LED CBA UNIT CN4101 CN3103 P-ON+5V 1 GND 2 (NO CONNECTION) AL+3.3V GND KEY-IN1 C3555 1000P CN3101 1 2 3 Q3501 2SC4081UBTLQ (SWITCHING) HDMI I/F C3551 OPEN R3554 OPEN C3552 OPEN CONTINUE DIGITAL 4 RESET PROTECT1 PROTECT3 D3301 EDZTE615.6B C3554 1000P R3312 R3313 R3314 R3315 R3316 R3341 C3217 C3218 C3223 C3224 R3340 C3219 C3220 C3216 R3335 100 R3336 100 R3322 0 R3325 0 D3813 1SS400TE61 10K 22 22 22 22 0 10 10 10 10 10K 10 10 10 R3812 2.2K C3812 100/16V R3806 10K C3809 1 R3811 R3810 20K 27K R3817 D3805 1SS400TE61 15K R3813 20K R3814 27K R3818 15K C3816 1000P C3813 100/16V 1 DRIVE 2 GND 3 RIPPLE FILTER C3817 C3810 1000P 1 R3803 10K 1 R3842 47K C3833 0.1 C3834 OPEN C3274 OPEN R3277 47K C3273 OPEN R3302 10K PWR M12 Q3201 2SK3018T106 (BUFFER) R3217 4.7K R3274 47K C3260 R3409 1 47K NU 14 6 NU 13 AUDIO I/F NU NU NU NU NU NU SPDIF N10 R3386 10K R3209 100 R3380 10K R3378 10K Q3031 2SA1576UBTLQ (SWITCHING) R3379 10K TO DIGITAL MAIN 2 IC3005(2/5) R3385 10K CPU-RESET-N J15 9 C3261 OPEN Q3033 2SC4081UBTLQ (SWITCHING) Q3032 2SC4081UBTLQ (SWITCHING) R3809 300 D3804 1SS400TE61 DIGITAL MAIN CBA UNIT Z CD 3 C3252 OPEN R3182 15K C3116 OPEN C3120 4700P C3113 0.033 NU 11 DRIVE R3731 180 NU 10 C3731 OPEN JK3731 HEADPHONE JACK C3732 OPEN L3731 OPEN R3823 1M R3827 10K D3808 MM5Z20B R3825 470K C3835 4.7 Q3805 2SC4081UBTLQ (SWITCHING) C3802 OPEN CN3802 1 SP(R) 2 SP-GND SP3802 SPEAKER R-CH C3801 OPEN CN3801 1 SP(L) 2 SP-GND SP3801 SPEAKER L-CH C3818 OPEN R3815 470 C3806 330/25V C3808 0.022 R3805 8.2 IC3009 PST8420UR (RESET) 1 GND OUT 4 R3732 180 C3805 330/25V R3816 470 R3178 10K 2 VDD C3106 0.1 CONTINUE DIGITAL 2 SPDIF CONTINUE DIGITAL 3 CPU-RESET-N D3108 EDZTE615.6B C3819 OPEN C3807 0.022 R3804 8.2 HDMICONNECTOR-1 TMDS-D2(+) D-SHIELD0 TMDS-D2(-) TMDS-D1(+) D-SHIELD1 TMDS-D1(-) TMDS-D0(+) D-SHIELD2 TMDS-D0(-) TMDS-CLOCK(+) C-SHIELD0 TMDS-CLOCK(-) HDMI-CEC NU HDMI-CLOCK HDMI-DATA GND +5V HOT PLUG DETECT R3374 1K R3191 100 NU 12 MUTE CONTROL JK3004 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 R3301 18K NU 15 Q3801 2SC4081UBTLQ (AUDIO-MUTE) R3808 3.3K Y AUDIO DECODER NU 17 5 GND 8 R3820 2.4K HDMI-SCL C16 HDMI-SDA C15 HDMI-HPD D14 NU 16 4 R3819 4.7K R3822 OPEN NU KEY-IN1 PROTECT3 LIGHT-SENS PROTECT1 LPF NU 18 7 VCC C3811 0.1 D13 A15 B13 A13 C13 C12 A8 B8 B7 A7 D11 D7 C6 C5 B6 A6 IC3801 TDA1517P (AUDIO AMP) D3814 EDZTE616.2B 2 Q3202 2SK3018T106 (BUFFER) R3216 4.7K C3301 0.1 C3231 0.22 CONTINUE DIGITAL 2 AUDIO(L)-IN AUDIO(R)-IN R3271 C3188 3K 2200P B1 A1 B2 A2 B3 A3 B4 A4 D3107 1SS400TE61 C3229 R3502 C3227 R3501 C3233 R3500 C3232 R3499 3 R3553 100 C3559 1000P C3556 100P C3186 4700P R3555 OPEN R3551 100 R3415 82K D3057 RB751S-40 C3185 R3270 C3187 0.01 2.2K 2.2 EXT-RES C4 PLL-XFC-A B5 PLL-XFC-P A5 VIDEO DECODER R3405 100 R3237 27K HDMI-CEC B15 TO DIGITAL MAIN 2 IC3005(2/5) R3186 39K R3317 10K R3318 20K R3319 10K TO IR SENSOR CBA UNIT CN4052 GND REMOTE AL+3.3V P-ON+5V LED1 KEY-IN1 LIGHT R3184 10K OPEN OPEN 330P OPEN OPEN OPEN OPEN OPEN 4 Q3014 2SK3018T106 (BUFFER) *1 IC3005(5/5) R8A05011BG-U0 DIGITAL SIGNAL PROCESS /MAIN MICRO CONTROLLER Q3010 2SC4081UBTLQ (BUFFER) AUDIO SIGNAL D3809 MM5Z20B R3824 1M R3828 10K R3821 OPEN AA BB 10-31 CC DD FL11.0SCDC5 Main CBA Top View [TYPE A] CAUTION ! Fixed voltage (or Auto voltage selectable) power supply circuit is used in this unit. If Main Fuse (F601) is blown , check to see that all components in the power supply circuit are not defective before you connect the AC plug to the AC power supply. Otherwise it may cause some components in the power supply circuit to fail. Because a hot chassis ground is present in the power supply circuit, an isolation transformer must be used when repairing. Also, in order to have the ability to increase the input slowly, when troubleshooting this type of power supply circuit, a variable isolation transformer is required. CAUTION ! : For continued protection against risk of fire, replace only with same type 4 A, 125V fuse. ATTENTION : Utiliser un fusible de rechange de même type de 4A, 125V. 4A/125V NOTE: The voltage for parts in hot circuit is measured using hot GND as a common terminal. D409 J117 P-ON-H2 R682 R632 R222 D417 D418 2 1 CN301 18 19 J174 D671 R634 J184 P-ON-H2 C691 J191 STRAT RES D634 D609 D605 R607 R608 R610 GND J189 FB1 R614 J190 D607 C603 D648 R609 01 D615 R612 Q6 TM602 D604 C692 IC601 C607 R611 CN601 J186 GND J187 FB2 13 D603 C601 +24V COLD D608 F601 4A/125V R243 C631 C693 R6 TM601 C636 J169 J183 D610 RISK OF FIREREPLACE FUSE AS MARKED C661 D655 D673 D674 AMP +11V C695 BC601 A3 R601 D656 D633 +31Vac T631 R662 15V-for-PANEL+13V D668 +24V J180 J178 +24V J179 C1011 D1021 R1030 J182 INV+24V J172 D602 SA601 T +24V D632 D601 HOT E234498 C401 R602 L601 CN1002 A17N5MPW 1 J168 C639 HOT C7A3 J164 GND J196 GND J170 GND R638 C632 D1028 R1032 BC1001 BA17N5F0101 1 TOOL NO. A B C D E F G H I J GND J176 GND GND R1091 COLD C1006 R1047 D1002 R1092 C1014 R1013 2 J151 Q636 J177 BC1002 D640 R673 J171 +5V 11V C642 C633 P-ON-H1 J162 ALL+5V 11V C644 Q635 R1007 R1008 R1010 D1029 C1019 R1011 2IN+ D1030 J173 T1002 C1012 J118 D207 R651 R652 J145 P-ON-H1 C204 J166 R671 P-ON-H1 D402 J128 11V J137 J140 J156 BL-SW J159 BL-ADJ D657 C643 Q1006-C Q1011 J147 Q202-C J134 R235 D404 R201 R208 R207 J160 +24V JS632 R1003 +5V R229 D405 D406 JS631 J149 J153 PROTECT1 C647 BC1003 C1022 J163 R1006 R1001 D1003 R1002 R1017 R1094 UVP2 R1093 J161 GND J158 BL-ADJ C212 C1015 P+13V-REG-VC J148 11V J154 BL-SW R1031 H.V CAUTION 3 C2 J139 Q206-B J142 Q401-B C205 J143 11V J155 GND J152 GND D201 D1017 J150 J192 J144 R1065 FB J146 C1 D642 D204 VGH+24V R1066 J141 J127 D649 D208 D1016 PROTECT3 J138 1IN- C1055 D1034 J133 DTC R1026 J136 D416 D651 Q634 R661 J130 J132 RT R649 R650 C209 VGL-7V J197 GND J123 D209-A C207 J115 VGH+24V D209 Q207 Q208 R656 C1010 J135 INV-TR-5PIN Q639-C D650 R239 R228 D1045 J131 C1008 R660 C640 C201 R241 R242 J124 PROTECT3 C217 R226 D1038 D1018 D1023 D1024 D1025 D1031 UVP1 J157 INV-HV R699 C652 LCD+13V J105 V-COM J175 GND J111 GND GND J193 J110 J107 BL-ON+15V C1053 LCD+13V VCOM-PWM D1022 R1029 C1013 D1020 J108 GND J119 C1027 UVP2 11 J104 P-ON+3.3V J122 PROTECT3 J126 INV-HV CN1001 CN201 D1001 D1036 C1033 J113 D1011-A J120 UVP2 J121 J125 GND C1009 J114 GND J194 4 D1060-A J109 D1004 J106 J102 VGL-7V 1 D1005 Q1009-C J100 10 J103 2 J101 BL-ON+15V Q602 FH602 A FH601 B C 10-32 D BA17N5F01011 Main CBA Bottom View [TYPE A] R1060 C1032 Q1015 R1014 R1012 C1003 R1023 R1022 Q1009 R1111 C1004 R1016 R1018 D1060-A J114 C1009 D1015 J125 D1023 CN1001 R1051 R1050 R1086 R1009 C1054 R1037 R1038 J157 INV-HV C1044 R1058 R1057 R1034 C1010 Q1014 C1021 R1056 R1043 C202 R1054 R1046 R1044 C210 D1009 R1072 C1058 R1094 R1093 R1017 C1029 R1073 R1071 D1003 C1048 C1050 Q1001 R1001 R1006 C1047 C647 C1036 C1017 C642 T1002 J173 2IN+ R672 R674 R675 R676 R1021 C1019 D1030 R1011 R1010 D1029 R1008 R1007 D637 D640 J171 +5V 11V J169 Q1017 C1049 Q1010 R1099 R1025 D638 JS632 C212 R207 R208 R201 D404 Q212 R244 D655 D673 D674 D657 R246 R245 R247 Q1006 R1003 R1002 R1070 R1069 C1034 R1074 C1020 R1068 R1031 R1005 R417 R205 D201 D1017 R418 D406 R209 R402 C1005 H.V CAUTION R1020 C1035 R1065 R210 R235 Q211 VGH+24V J147 Q202-C J134 R1004 Q1016 Q1007 C1028 C1056 R1084 C1037 Q1019 C1040 R1042 R1049 R1067 Q1004 R1048 Q1002 R1066 Q1012 R1026 R236 C208 C211 R229 R416 D405 R206 C203 R1109 R1055 C1031 R1045 R1040 R1112 R1052 Q210 D1016 R1053 R415 R204 R1028 D1045 R1027 C1045 R203 R202 C1024 R1107 R1110 C1027 C1025 R1041 R1036 C1001 C1030 UVP2 D1013 D1001 D1036 R1087 C1041 R1089 R1090 C1043 R1088 R1059 C1033 R1019 J113 D1011-A D1006 D1011 D1010 R1061 D1004 R1015 C1013 Q1003 D1020 R1029 R1081 Q1024 R1105 Q1023 R1106 D1018 R242 J124 PROTECT3 R241 C214 R226 R224 R239 R228 R225 R227 R237 J115 VGH+24V R211 R212 Q202 D402 R1030 R1024 R1035 D633 C1007 C1046 C1059 C1023 C1002 R1092 R1091 R1013 J180 J179 R1039 +24V D670 J178 +24V C1011 J182 INV+24V C1038 D1021 C1018 R1032 R1047 D1002 D631 R662 15V-for-PANEL+13V D668 D1028 C1026 C632 D639 D636 R401 D401 D671 R634 R633 C646 Q633 R648 J184 P-ON-H2 C691 C656 R603 R604 D634 R647 Q641 R639 CN1002 R640 R643 R607 R605 BC601 D602 C645 D609 D605 Q631 C635 R641 R608 D608 R642 SA601 R606 C604 C602 R609 R636 D648 D656 R638 C601 D610 R611 R612 R614 GND C603 R610 C606 J189 C605 BA17N5F01011 10-33 A B D1022 R1082 R1083 C1039 C1042 C1053 C1016 C215 C201 J193 R1095 GND J111 GND J110 J107 BL-ON+15V C221 C219 C218 GND Q209 R234 R646 R656 R661 J130 R214 R221 R631 C636 J174 D672 CN601 FH602 FH601 1 R601 D604 D615 3 C1015 UVP2 C685 CN301 19 +24V Q6 01 NOTE: The voltage for parts in hot circuit is measured using hot GND as a common terminal. C220 J105 V-COM J175 LCD+13V J103 C216 R233 R230 R232 R231 VCOM-PWM C638 J123 D209-A R649 R650 R652 +5V R213 R651 Q206 C667 C666 C664 C663 C668 18 Q602 C D R655 R653 R240 C641 R635 C207 D207 R223 R220 Q401 D418 R403 C402 1 2 C631 L601 R602 C1014 C1006 BC1001 C693 2 AMP +11V F601 4A/125V J190 D607 FB1 D603 C607 13 R6 IC601 C637 R670 J118 C206 D417 C665 T631 J177 C1055 C669 J176 GND 4 C633 BC1002 J172 +31Vac D601 J191 STRAT RES J187 FB2 J186 GND C652 C634 C640 Q639 R222 R243 R632 R682 C662 C695 R699 D409 R666 VGL-7V J197 GND R668 Q400 J117 P-ON-H2 R413 R677 Q636 GND D632 C1012 R673 5 8 J131 R406 C692 R660 R667 R414 R408 J183 C639 Q1006-C 1 Q635 C401 Q1018 J163 BC1003 R671 11V C644 J168 +24V C643 Q1005 Q1011 J128 11V C204 J166 J196 GND J170 GND J164 GND JS631 C1022 J145 P-ON-H1 J162 ALL+5V J152 J155 GND J158 BL-ADJ J160 +24V J159 BL-ADJ J143 UVP1 4 Q638 R669 C661 Q402 R407 P-ON-H1 J144 GND J192 C205 J154 BL-SW J151 J149 P-ON-H1 J153 PROTECT1 J156 BL-SW GND J150 C2 C1008 D1034 FB J146 C1 11V J148 11V P+13V-REG-VC Q203 J161 GND J140 J141 J137 Q1008 J132 8 RT J133 DTC J136 PROTECT3 D204 Q207 9 J135 INV-TR-5PIN 1 Q208 C209 D649 J122 IC202 J138 1INJ139 Q206-B J142 Q401-B D208 D642 D209 J127 PROTECT3 INV-HV J126 16 IC1001 Q634 4 IC1002 8 D1025 D1031 D1038 D651 J120 UVP2 J121 D1024 D650 5 Q639-C J109 5 LCD+13V 1 IC201 4 1 Q1009-C J194 GND 8 J106 J108 1 CN201 11 BL-ON+15V VGL-7V D1005 J104 P-ON+3.3V 4A/125V GND J119 C217 D416 IC631 J100 CAUTION ! : For continued protection against risk of fire, replace only with same type 4 A, 125V fuse. ATTENTION : Utiliser un fusible de rechange de même type de 4A, 125V. CAUTION ! Fixed voltage (or Auto voltage selectable) power supply circuit is used in this unit. If Main Fuse (F601) is blown , check to see that all components in the power supply circuit are not defective before you connect the AC plug to the AC power supply. Otherwise it may cause some components in the power supply circuit to fail. J101 2 10 J102 GND Because a hot chassis ground is present in the power supply circuit, an isolation transformer must be used when repairing. Also, in order to have the ability to increase the input slowly, when troubleshooting this type of power supply circuit, a variable isolation transformer is required. Main CBA Top View [TYPE B] CAUTION ! Fixed voltage (or Auto voltage selectable) power supply circuit is used in this unit. If Main Fuse (F601) is blown , check to see that all components in the power supply circuit are not defective before you connect the AC plug to the AC power supply. Otherwise it may cause some components in the power supply circuit to fail. Because a hot chassis ground is present in the power supply circuit, an isolation transformer must be used when repairing. Also, in order to have the ability to increase the input slowly, when troubleshooting this type of power supply circuit, a variable isolation transformer is required. CAUTION ! : For continued protection against risk of fire, replace only with same type 4 A, 125V fuse. ATTENTION : Utiliser un fusible de rechange de même type de 4A, 125V. 4A/125V J059 DIF J060 28 DIF + 2 1 forA J086 1 2 29 1 2 J082 J044 M+9V S-SW D415 D412 D407 29 Q171 GND J183 P-ON+9V 28 GND J108 JS101 DVD-LED GND J075 P-ON+9V C831 Q172 08 D9 J030 GND Q801 C910 2 1 C838 J028 SP-GND C654 D665 8 J019 RIPPLE REJECTION J007 AMP-L-HP J008 SP-GND J084 GND J181 GND IC801 D808 J072 A-Protect D805 CN102 1 GND D804 D D809 AMP-R-HP J021 AMP-R-HP J020 J009 D414 C813 J065 GND R635 J029 P-ON+9V J247 SP-GND C812 R638 J032 R675 J230 M+10V SW C653 GND R806 J077 R807 Q641 J105 SP+14V 31V P-ON+9V GND D909 D907 C921 D666 R906 D645 R637 P-ON+9V J026 J027 GND GND GND C917 R676 D902 C918 C916 R932 C919 J080 D903 J104 J103 J107 GND D901 R927 J074 GND J022 CN702 R919 Q905 GND 25 J025 Q904 R929 J081 J038 C806 D905 R925 CN901 J185 GND D413 R838 Q903 J042 GND D906 R928 R926 R924 J083 26 2 GND J073 GND 13 R922 29 CN302 J062 GND GND J043 28 CN303 P-ON-H1 KEY-IN1 AMP-L J017 J069 GND J125 P-ON+5V R172 C928 J079 DVD-A-POW J036 J046 J070 P-ON+5V GND C904 J033 J159 SP-GND J035 P-ON-H2 GND LCD+13V DVD-MAIN-PWR J124 R905 R923 R658 C645 10-34 AMP-R LED-R J040 LED1 J041 J054 PROTECT1 J039 J149 GND J050 R826 R904 GND J037 J126 Q631 D656 C J034 J066 P-ON-H2 P-ON+3.3V RCV-IN ALL+3.3V J049 J051 Q902 R649 R652 R679 R917 J195 GND IC901 D646 CN301 C306 J003 GND J071 GND ALL+3.3V J018 D653 J068 LED1 D657 D411 DVD-Pb D642 Q901 R682 GND J242 A-MUTE Q634 D650 Q907 CN902 1 P-ON SW GND IC601 J180 C608 J246 GND J187 6.7Vfor1.0V 3.5Vfor1.8V R240 J151 L301 R215 D203 Q202 J161 J157 INV+31V D670 29 28 J106 GND R411 P-ON+5.0V J119 P-ON+3.3V J067 RCV-IN J109 GND J152 GND GND J150 D410 J153 J127 GND D409 J205 Q402 GND R406 GND R698 D408 D209 R662 D651 D416 J045 D647 D648 J102 Q602 J055 GND J061 D649 D904 J047 GND J052 GND C604 Q601 R611 B ALL+3.3V DVD-LED JS103 R634 D644 R608 C606 D609 C607 Q633 D606 R609 R612 R606 0 R61 COLD A J053 12 2 C643 C6 91 D610 C692 R603 R604 01 FH6 / BLACK LCD+13V C204 J186 GND R665 R913 C640 J237 31V D638 PCB STUD R912 R607 C605 TRANS-D CN862A 1 C819 D643 R605 D608 J048 D302 D301 IF-AGC D417 1 HOT D605 BC601 D607 / WHITE RISK OF FIREREPLACE FUSE AS MARKED TM601 AC601 TM602 J011 Q906 4 R91 R930 FET-G SCL SDA J010 C647 T601 J100 J056 DVD-Y L901 D401 D636 D631 D604 D601 D612 02 FH6 R601 CN872 F601 4A/125V HOT 83 J188 31V C601 TU301 TU302 R680 J231 P-ON-H2 D640 COLD SA601 J192 D641 CN1002 R6 C638 C603 C650 INV+31V A01NMPW E234498 T Q401 J236 31V D611 C648 J239 C7A3 A3 D639 J189 31V J128 PROTECT2 for TU+5V R6 84 C639 R689 R602 TOOL NO. A B C D E F G H I J 2 GND R651 R688 D637 R631 D602 J141 ALL+3.3V J140 GND R661 R656 C636 L601 TUNER A S TU+5.0V J101 J142 GND J137 P-ON+5V R650 Q643 C633 HOT LCD+13V for ALL+3.3V J111 J120 ALL+3.3V IC631 D632 D402 C401 D668 C631 D603 R699 Q209 J177 GND D202 R218 J154 GND R2 01 R6 59 C632 D1037 D633 COLD P-ON-H1 J160 D652 C641 J002 GND J147 Q637 J232 D654 C1014 J063 GND PROTECT2 D659 J136 GND J1015 31V GND J245 J001 PROTECT D303 J191 GND J138 D655 3 J224 D406 C217 LCD+13V J229 C209 Q201 R222 Q206 VGH+24.5V GND J117 J118 J076 GND J078 15V R1097 J122 31V BA01NDF0101 4 C1011 Q203 GND GND J148 P-ON-H2 J123 for TU+5V J139 INV+31V J135 GND INV+31V C303 Q636 J234 RESET J134 P-ON-H2 J114 6.7Vfor5.0V P-ON+3.3V J133 for P-ON+5V R690 JS307 5V-S J085 J197 J193 R1096 P-ON-H2 D1019 J113 R671 J165 GND Q1012 R1031 Q1011 D667 R663 32V-S JS308 5V-A JS306 forS C649 Q635 R933 D662 VT+32V D208 GND J146 J145 GND J144 5.5Vfor3.3V J143 5.5Vfor3.3V GND 32V-A JS305 D403 J194 R1117 C655 J1001 15V R655 Q640 J1017 C1002 D1021 J132 GND J131 J129 5.5Vfor3.3V R1118 R670 R1034 J158 VGH+24.5V J176 VCOM-PWM Q1023 ADJ SW J200 Q1024 R1108 JS1005 J241 GND R1100 J227 GND R1033 C652 J163 P-ON+5.0V D404 J240 J162 J170 LCD SW GND 6.7Vfor1.0V J058 TU+5V J190 GND R217 J164 LCD+13V J166 J130 5.5Vfor3.3V Q639 Q638 C1059 R1013 R219 Q205 R664 D1046 D661 R235 R216 J116 J215 REG R239 D205 D204 J057 J064 C205 R207 R208 Q1020 D660 C661 J1005 GND R1032 D C1012 D1047 JS1011 D1002 R1092 D210 J1006 VT+32V GND Q210 R229 D201 Q1002 Q208 D206 C201 D207 J209 R228 J178 LCD+13V VGL-7.1V J172 R1047 J1004 GND J174 VCOM J175 R672 R1026 D1030 C1019 J1018 GND T1002 H.V CAUTION R1091 C1006 C207 R226 Q207 R223 J1003 2IN+ D1028 PROTECT3 VGL-7.1V GND J171 LCD+13V D1045 Q1008 R1102 J203 G R1030 P-ON+3.3V J179 J169 J228 R1008 D1029 D405 Q1004 D1031 Q1006 JS1012 D1040 4 JS1004 IC Vcc D1018 R1101 R1003 J173 GND J167 BL-ADJ J168 BL-SW C1027 C1023 J208 DRIVE R1065 R1049 R1066 GND J214 BL-ON 15V R1074 Q1018 Q1017 R1007 D1003 R1103 JS1013 G JS1007 DTC R1029 GND Q1016 D1020 D1025 Q1001 JS1010 D C1015 CN1001 J210 2IN+ J204 R1006 R1010 C1005 C1058 D1015 D1013 C1001 R1094 D1008 R1017 D1012 C1007 D1007 D1014 D1026 Q1007 D1009 D1011 C1008 GND R1002 J213 D1027 J211 C1 BL-ON 15V D1022 D1006 R1001 J221 D1036 D1035 J222 C1033 D1010 Q1015 D1023 J201 GND C1009 R1044 R1093 D1005 GND J225 GND Q1009 J223 R1012 D1001 D1004 R1014 R1111 C1013 Q1003 C1053 JS1006 FB GND J199 D1024 J220 -INB D1041 D1038 REF+5V R1095 C1031 J216 -INA C1010 CN201 D1033 Q1010 Q1014 J1002 GND D1039 D1034 5 C1055 Q1019 Q1025 GND J226 R1113 D1016 J219 BL-ON+15V NOTE: The voltage for parts in hot circuit is measured using hot GND as a common terminal. C805 E BA01NDF01014 Main CBA Bottom View [TYPE B] CAUTION ! Fixed voltage (or Auto voltage selectable) power supply circuit is used in this unit. If Main Fuse (F601) is blown , check to see that all components in the power supply circuit are not defective before you connect the AC plug to the AC power supply. Otherwise it may cause some components in the power supply circuit to fail. Because a hot chassis ground is present in the power supply circuit, an isolation transformer must be used when repairing. Also, in order to have the ability to increase the input slowly, when troubleshooting this type of power supply circuit, a variable isolation transformer is required. CAUTION ! : For continued protection against risk of fire, replace only with same type 4 A, 125V fuse. ATTENTION : Utiliser un fusible de rechange de même type de 4A, 125V. 4A/125V NOTE: The voltage for parts in hot circuit is measured using hot GND as a common terminal. D1004 R1014 D1001 D1010 D1012 C1008 R1012 J223 D1026 D1014 D1007 D1011 C1013 R1016 R1111 GND Q1009 J225 GND R1019 C1033 Q1015 C1001 CN1001 C1015 Q1005 C1003 R1023 R1022 R1018 R1081 R1082 R1083 R1086 C1039 R1087 D1042 D1032 C1032 R1060 R1061 C1019 D1030 C1026 R1026 4 JS1011 R1032 D C1012 D1047 R1091 C1006 C1059 R1013 Q640 R1035 C651 R655 R674 J1001 15V H.V CAUTION T1002 Q1022 D1046 J1018 GND R1024 R673 Q638 R1033 R1097 D662 C218 Q1019 D1005 R1015 D1036 D1035 D1008 R1017 C1007 R1094 R1093 D1015 D1013 R1084 C1040 C1055 R1056 D1034 R1058 C1044 R1059 R1057 R1116 R1112 D1009 C1004 R1092 R1039 C1002 D1021 C1038 C1018 J245 GND J1015 31V C1011 C632 84 D633 D641 D401 R631 J236 31V D612 91 C6 D644 C692 D610 R634 D605 FET-G R605 BC601 CN872 R601 FH6 01 D607 D608 R611 1 AC601 R61 C801 0 CN862A R636 C645 J180 C608 TRANS-D IC601 C607 Q601 J102 GND R641 R609 R612 Q602 D609 C606 C604 SA601 R604 D606 J100 FH6 02 R603 C820 R640 R681 R653 R654 D646 GND J052 R647 R646 R658 R638 J065 GND R635 R639 J072 A-Protect R409 GND J181 C819 Q631 D656 R642 R643 R644 R645 AMP-R-HP J021 C813 D809 R804 C807 R816 C811 R818 C808 R815 GND J084 D648 C601 R606 R608 J103 R807 GND R806 J077 J104 Q633 D611 C603 R607 C605 R637 C812 D601 C643 C644 T601 P-ON SW 31V J105 SP+14V Q641 D647 2 D643 J047 GND C916 D902 C918 D903 31V J237 IC901 C646 C919 C920 R930 L601 31V J189 J188 31V R912 GND J042 D906 R920 R927 D638 C638 D602 D604 R401 C640 R913 GND R928 Q903 R929 D603 R602 J242 C901 R902 R901 R925 D631 D636 L901 R942 R941 R923 C1014 CN1002 C636 Q401 3 J001 PROTECT C1021 C633 R1064 J192 GND C904 R933 C924 C922 C928 R936 1 GND J002 D632 C402 R689 R404 C923 J195 GND IC631 C631 D637 C639 D1037 C401 D402 R402 R403 D668 R1050 R1051 R1062 R1009 R688 R686 R685 D654 D640 Q904 C1009 D1027 5 Q1003 JS1010 D D1003 D1039 R1011 R1021 R667 R666 R668 R669 R1096 D1002 R671 D639 CN902 R922 C1010 D1006 D1022 C1041 R1088 D1025 Q1001 C1005 C1036 C1058 R1103 Q1017 C1017 C1049 R1025 R1102 R1101 Q1018 C1034 R1068 Q1010 R1067 J208 DRIVE C1052 Q1008 15V J078 J227 GND D667 R1114 J219 J213 C1042 R1001 J221 GND C1048 D1020 Q1016 R1029 R1104 C1047 BL-ON 15V R1066 R1041 R1040 R1036 R1049 R1028 D1018 R1027 C1023 R1100 R1099 R1031 GND J076 C652 R670 C1057 R1115 R1113 BL-ON+15V R1037 C1025 R1045 R1038 R1043 R1046 C1028 R1055 C1053 FB JS1006 Q1004 GND J241 Q1012 R1004 R1005 JS1004 C1054 IC Vcc D1031 JS1005 DTC JS1007 R1108 C1016 GND R1002 G J1017 VT+32V Q1014 J201 GND J215 REG 59 R6 R682 Q901 13 Q905 R676 C654 R817 R808 R819 R805 J025 D REF+5V R1052 R1042 R1048 R1118 R1034 R1117 C655 R6 83 2 D645 D414 R1054 C1056 R1109 R1095 C1045 J200 ADJ SW R1110 R1107 Q1024 R1053 D661 C641 4 12 R932 D666 R842 C833 R820 R809 J019 RIPPLE REJECTION J007 AMP-L-HP SP-GND J008 J1004 GND J1005 GND J113 R91 R924 C653 R675 C821 Q801 D665 IC801 D808 C656 D901 R910 R911 C912 C921 C914 C910 C810 R803 J230 M+10V SW 2 R906 C661 Q639 J114 R1020 R1089 R1072 C1037 R1071 R1073 GND C1043 J226 C1035 C1050 R1090 R1069 R1070 C1031 R1106 Q1023 C1024 D660 D1023 J222 D1040 JS1012 D1028 Q1020 Q643 D905 J107 GND C917 08 R931 J073 R919 D907 D909 J029 P-ON+9V C805 C902 BC902 R921 R943 C927 R940 GND C925 C802 C809 C816 C817 R810 R814 R813 C806 1 E IC902 J080 J074 GND D9 D805 R905 R926 GND J185 GND J030 GND 1 C907 CN901 J081 R935 C926 C906 R903 C203 25 D1029 R1030 2IN+ -INB J220 D1016 D655 8 1 P-ON+9V GND 5 Q907 2 GND J032 1 C903 C915 C911 GND BC801 C830 R834 C828 R811 C832 J022 R904 4 J079 DVD-A-POW 26 J083 C831 Q172 R838 R171 R173 D413 C913 C908 C909 C826 DVD-LED JS103 C838 D804 J117 J232 R656 R918 C929 J183 P-ON+9V D904 Q906 BC901 J045 J075 P-ON+9V R908 R909 C829 R826 GND D412 R917 R907 J070 P-ON+5V J108 D407 Q634 D650 R1007 31V J122 R650 R652 J124 5 8 J009 GND J118 INV+31V G JS1013 R6 J053 R649 P-ON-H2 GND R648 GND J038 CN702 C818 GND GND R1010 R1008 J203 J1003 J116 D1019 J123 J139 INV+31V Q1006 Q1011 J130 R1065 R1003 Q1007 R1006 R1047 R664 INV+31V J050 M+9V J044 R830 R823 R175 R174 29 CN102 C1020 5.5Vfor3.3V VGH+24.5V J131 J129 R690 for ALL+3.3V J111 J120 ALL+3.3V R651 GND J214 BL-ON 15V R1074 D1024 GND J136 C647 Q902 R821 C825 R172 Q171 JS101 DVD-LED 28 J020 Q206 GND 5.5Vfor3.3V 16 D670 C905 J037 GND R836 J126 P-ON+5V J125 8 AMP-R-HP R222 J132 P-ON-H2 R665 Q637 D651 D416 R915 R916 R413 R414 R837 C827 R678 LCD+13V DVD-MAIN-PWR J046 IC803 1 4 J051 GND D415 J028 SP-GND J154 GND GND 1 9 Q1025 -INA J216 IC1002 R1044 8 J210 2IN+ J204 VT+32V 2 J082 J247 SP-GND R221 C206 01 R2 GND J165 J186 GND J034 J035 J033 J017 J069 1 GND J036 GND P-ON+9V J026 J027 GND C1027 Q1002 GND J199 IC1001 C1 J211 R672 6.7Vfor5.0V GND J135 D649 R679 GND C221 C215 Q201 R220 R202 C304 J163 D1041 D1038 D1045 D652 GND J055 J061 A-MUTE S-SW C219 R225 R224 R237 R238 J229 C202 R203 R218 R662 D642 J049 DVD-Pb J149 J039 J040 J041 J054 J159 AMP-R SP-GND AMP-L P-ON-H1 CN303 KEY-IN1 for TU+5V J231 P-ON-H2 J166 GND J134 P-ON-H2 J148 P-ON-H2 for TU+5V J239 C650 R205 D202 R204 R661 DVD-Y C213 C212 C210 C211 R227 C214 J157 R633 P-ON+3.3V RCV-IN ALL+3.3V LED1 PROTECT1 LED-R 29 J234 RESET C648 R223 D204 GND J209 J1006 R663 J133 for P-ON+5V D659 ALL+3.3V C204 LCD+13V J164 D207 D210 J1002 D1033 J194 J138 J048 J170 LCD SW J193 GND GND R660 GND J128 PROTECT2 C220 R210 J177 GND INV+31V D203 Q202 R632 28 D417 Q636 C207 R208 GND J146 J145 GND 5.5Vfor3.3V J144 5.5Vfor3.3V J143 C649 Q635 J137 P-ON+5V R1105 C209 Q209 R214 R212 J197 J101 J142 LCD+13V C216 R230 C217 R232 R231 R233 R234 R217 D403 GND J171 LCD+13V J172 C201 R216 J161 LCD+13V D657 D411 GND R219 R215 J160 VCOM J174 J175 R207 Q205 R405 LCD+13V R206 D209 R240 J147 8 J179 J169 PROTECT3 J228 VGL-7.1V D201 C205 D205 D208 R213 J162 P-ON-H1 R209 D406 J158 VGH+24.5V J176 VCOM-PWM R699 R698 D408 R211 Q203 ALL+3.3V J141 GND J140 J066 IF-AGC J153 J190 GND PROTECT2 R239 BL-ADJ J167 BL-SW J168 J178 LCD+13V VGL-7.1V D206 R235 R412 J010 J011 P-ON-H2 2 WF1 PIN 4 OF CN302 TU301 TU302 R680 R677 GND J043 1 WF3 PIN 6 OF CN302 J056 SCL SDA 3.5Vfor1.8V 6.7Vfor1.0V J187 J151 C301 C685 L301 C309 R303 TU+5.0V D301 Q208 CN201 J173 GND P-ON+3.3V IC201 5 R229 GND J191 R176 GND R302 CN302 J062 TUNER S A D302 R228 Q210 C303 D303 1 4 Q207 D410 J152 JS303 R313 C315 C314 JS301 JS805 JS804 JS801 JS802 29 forA J086 J059 DIF J060 DIF + 28 2 WF2 PIN 8 OF CN302 GND J240 P-ON+3.3V 1 WF7 PIN 13 OF CN302 R406 J085 D404 JS803 R226 J064 5V-S JS307 forS GND J063 GND R407 J224 J205 R408 GND Q402 D409 JS306 GND J109 C306 TU+5V GND J150 P-ON+5.0V J119 P-ON+3.3V J067 RCV-IN 32V-A JS305 C302 C311 C310 ALL+3.3V J018 BC301 D653 J068 LED1 R304 R307 R305 R306 JS304 L303 L302 5V-A J071 GND C305 J058 P-ON+5.0V 32V-S JS308 R411 J127 GND J106 GND J057 6.7Vfor1.0V C681 J003 GND GND J246 CN301 WF5 PIN 17 OF CN302 WF4 PIN 15 OF CN302 C683 C684 C682 28 29 WF6 PIN 19 OF CN302 D405 C 10-35 B A BA01NDF01014 Main CBA Top View [TYPE C] CAUTION ! Fixed voltage (or Auto voltage selectable) power supply circuit is used in this unit. If Main Fuse (F601) is blown , check to see that all components in the power supply circuit are not defective before you connect the AC plug to the AC power supply. Otherwise it may cause some components in the power supply circuit to fail. 4A/125V Because a hot chassis ground is present in the power supply circuit, an isolation transformer must be used when repairing. Also, in order to have the ability to increase the input slowly, when troubleshooting this type of power supply circuit, a variable isolation transformer is required. CAUTION ! : For continued protection against risk of fire, replace only with same type 4 A, 125V fuse. ATTENTION : Utiliser un fusible de rechange de même type de 4A, 125V. NOTE: The voltage for parts in hot circuit is measured using hot GND as a common terminal. 1 6 1 FH601 BC1002 C1018 C1010 FH602 F601 4A/125V 6 CN1002 CN1001 D1002 C628 JS1001 GND C1003 SA601 J1001 D1003 LED-VIN 7 00 R1 RISK OF FIREREPLACE FUSE AS MARKED J1004 J1006 BC1001 Q607 L601 BC601 BL-SW J114 LDR J1013 GND VIN D1004 R1030 J1010 C632 T601 D615 C612 D611 D610 J002 SOURCE D612 J1007 GND R1031 D619 J001 D609 D1005 C616 GATE C622 C617 C633 R634 D601 BA1170F0101 1 R625 BL-ADJ L1001 C626 CN603 D1001 C607 J1009 R626 J008 GND J003 C630 FOR START RES J118 -15V J119 D663 R661 R655 5V A3 R682 R656 J104 D635 R657 Q611 D637 D641 D662 J109 ALL5V J110 GND J111 P-ON-H2 D665 GND J009 D664 18 J115 R636 19 GND R635 1 D640 D638 R677 R681 R642 R680 D618 D613 Q608 BC001 P-ON21VUP-15VA 2 CN601 C7A3 D658 SP+11V R654 D636 J106 J105 PROTECT1-AMP11V J113 10-36 D608 Q616-B R643 IC601 COLD R633 D617 D614 R683 R640 FB J107 J117 AMP11V J116 D642 J007 AMP11V D634 D630 R639 D616 C623 SOURCE HOT J006 D631 D660 R631 R632 C608 J120 GND P-ON21V-UP-15VA J101 C627 GND J108 P-ON5V J004 D620 BA1170F01011 Main CBA Bottom View [TYPE C] C1005 C1006 C1007 C1008 C1009 R1009 R1004 R1003 C1011 R1002 C1010 C628 C1018 C1020 C607 C626 CN603 R625 R1 00 D1003 LED-VIN J1001 SA601 L601 BC601 Q607 R1030 Q1001 C1002 LDR J1013 GND VIN BC1001 C1001 Q1003 C1012 C1003 J1006 C1013 C610 D629 10-37 D610 D611 R634 R627 R628 R630 R629 D617 BC001 Q608 R635 1 D614 C611 D618 D613 R633 C614 R636 COLD R680 R642 R681 R632 R631 HOT Q609 C625 R643 J007 R647 C644 R650 SOURCE D616 FB J113 C608 J006 R640 R641 R646 D634 D642 R648 R649 R677 C640 GND J004 IC601 P-ON21VUP-15VA CN601 2 J003 FOR START RES J120 GND R683 R645 Q631 R678 Q616 D638 C643 19 C612 D615 GATE J001 D627 D631 D660 Q610 R653 R652 C623 D630 R639 R623 R624 D640 ALL5V J110 GND J111 18 J002 SOURCE T601 C632 R673 C624 D661 R686 C639 C636 C634 C637 C635 GND J115 R685 J117 AMP11V J116 R679 J107 D641 D637 C642 D635 R657 C638 Q611 C641 D662 R682 R656 GND J009 D664 AMP11V J108 P-ON5V J106 SP+11V R654 D636 D658 R661 R655 R674 R675 D663 D665 C627 Q616-B J109 J101 R676 P-ON21V-UP-15VA PROTECT1-AMP11V 5V J104 D608 D601 R626 D620 J118 -15V J119 J105 D657 C616 C622 C617 C630 Q615 C631 J008 GND D609 D619 P-ON-H2 C633 D1005 D612 C613 C1004 R1033 R1028 R1029 R1026 Q1002 R1025 R1031 R1032 R1013 J1010 GND J1007 R687 R1021 24 J1004 BL-SW R1027 J114 R1023 FH602 F601 4A/125V 7 JS1001 BC1002 D1001 L1001 1 R1006 R1005 D1002 J1009 R1012 BL-ADJ IC1001 6 CN1001 C1016 R1015 R1020 R1010 R1019 FH601 CN1002 13 R684 NOTE: The voltage for parts in hot circuit is measured using hot GND as a common terminal. 1 GND D1004 CAUTION ! : For continued protection against risk of fire, replace only with same type 4 A, 125V fuse. ATTENTION : Utiliser un fusible de rechange de même type de 4A, 125V. 4A/125V 1 6 12 R1011 C1015 R1022 C1017 CAUTION ! Fixed voltage (or Auto voltage selectable) power supply circuit is used in this unit. If Main Fuse (F601) is blown , check to see that all components in the power supply circuit are not defective before you connect the AC plug to the AC power supply. Otherwise it may cause some components in the power supply circuit to fail. Because a hot chassis ground is present in the power supply circuit, an isolation transformer must be used when repairing. Also, in order to have the ability to increase the input slowly, when troubleshooting this type of power supply circuit, a variable isolation transformer is required. BA1170F01011 Jack CBA & Function CBA Top View [TYPE B] SW109 POWER JK751 / JK752 YELLOW CN862B P b P b CL862 / ORANGE / WHITE / WHITE JK753 J814 JK722 GND JK754 / RED / RED / RED / RED JK733 BC771 JK851 D706 L854 D705 1 C7A3 L853 L851 R851 J808 HP-GND HP-GND L852 AMP-R-SP J805 J804 J806 AMP-L-HP CN861A J816 GND D709 4 2 R852 CN871 A3 1 BA01NDF01023 10-38 SW951 PLAY STOP SW952 J803 GND / / WHITE BLUE JK732 J811 SEL-R 28 R789 SW953 EJECT SW108 CH.UP SW107 CH.DOWN MENU SW106 VOL.UP SW105 / GREEN R774 R775 V-R CL861 R954 C951 D951 C109 R116 COM-Y P-ON+9V R763 C103 D105 SW104 VOL.DOWN JK731 J807 J809 2 1 29 J820 GND A BA01NDF0102 3 R788 Q771 C108 J901 RCV-IN D104 CN101B CN101 J819 CN701 J815 PC AUDIO-L J817 3 J802 SP-L-GND J821 J801 Q722 Q773 C771 AMP-L-SP R782 Q774 JK711 BA01NDF0102 GND J822 V-R J812 JK742 J813 PC-AUDIO-L JK721 JK741 C7A3 A3 CN861B P b R757 R758 JK841 J818 SPDIF R756 Q841 J810 P-ON+9V POW. CN101A JACK CBA SW954 AGING R951 D952 RS101 BA01NDF0102 3 ST.BY D103 DVD D950 PATTERN SW955 R106 R950 /GREEN /RED /ORANGE B LC8 19/22W BASE Not Used Not Used Function CBA Not Used Jack CBA & Function CBA Bottom View [TYPE B] Not Used Function CBA Not Used C105 C110 J803 GND C755 C731 R843 R731 C845 R763 R786 R793 R732 R733 JK742 GND J822 CN701 J811 SEL-R JK722 JK754 V-R J812 R755 JS701 R741 C732 R747 R721 V-R JK753 C743 R794 J819 R787 C773 R735 C735 C723 R727 R764 JK732 R754 C736 R742 D704 C724 R722 R736 R781 R790 R777 R773 16 1 R797 IC771 D706 Q771 R796 J820 GND R779 C775 Q722 R772 Q773 8 C776 D710 C771 J816 GND L853 L851 J808 HP-GND J821 R778 J801 AMP-L-SP J802 SP-L-GND R852 C861 CN871 AMP-L-HP J806 HP-GND R776 CN861A C772 C852 AMP-R-SP J805 J804 D703 D705 L854 C851 Q774 R782 C733 D701 R784 R748 9 JK851 R788 R780 D702 J817 C744 3 J815 D708 R791 BC771 R783 PC AUDIO-L D707 R789 JK733 R728 10-39 CN101A CN101 C841 JK741 R775 R774 R785 R718 JK721 R792 R717 J813 C757 PC-AUDIO-L GND J814 JK752 C734 R848 C704 C703 R795 C758 R734 R844 BA01NDF0102 R712 R711 R753 COM-Y R752 J807 C756 JK711 J809 JK841 C752 C753 J818 SPDIF R757 R758 JK731 JK751 Q841 P-ON+9V C754 R751 BC841 C842 R845 J810 P-ON+9V R847 R846 C843 R756 C751 SW104 VOL.DOWN R111 VOL.UP SW105 SW107 CH.DOWN MENU SW106 SW108 CH.UP JACK CBA R851 CN101B R112 R114 SW951 PLAY STOP SW952 D951 C109 R956 C951 R115 J901 RCV-IN D952 R118 R113 R116 R955 R953 R954 D104 C103 SW109 POWER C950 R950 R106 R951 R952 L852 CL861 CL862 P C111 PATTERN SW955 DVD D950 ST.BY D103 SW953 EJECT CN861B CN862B POW. C104 SW954 AGING C106 R108 R107 D105 R109 D709 C107 C108 D101 RS101 R110 P b Not Used BA01NDF01023 b P b WAVEFORMS [TYPE A, TYPE C] WF1 ~ WF4 = Waveforms to be observed at Waveform check points. (Shown in Schematic Diagram.) Input: Component Color Bar Signal (480i, 480p, 720p or 1080i) (with 1kHz Audio Signal) WF1 JK3701(Y-IN) VIDEO-Y WF2 AUDIO 0.2V 20µs JK3701(Pr-IN) VIDEO-Pr WF4 20µs JK3701(Pb-IN) VIDEO-Pb WF3 0.2V 0.2V 20µs JK3701(AUDIO(L)-IN) 0.1V 11-1 0.5ms FL11.0AWF [TYPE B] WF1 ~ WF7 = Waveforms to be observed at Waveform check points. (Shown in Schematic Diagram.) Input: NTSC Color Bar Signal (with 1kHz Audio Signal) WF1 Pin 4 of CN302 CVBS WF2 0.2V WF6 20µs 0.2V 20µs AUDIO 0.2V 20µs Pin 19 of CN302 VIDEO-Pr WF7 0.2V Pin 17 of CN302 VIDEO-Pb Pin 6 of CN302 S-VIDEO-C WF4 20µs Pin 8 of CN302 S-VIDEO-Y WF3 WF5 0.2V 20µs Pin 13 of CN302 0.1V 0.5ms Pin 15 of CN302 VIDEO-Y 0.2V 20µs 11-2 FL11.0BWF CN3102 1 2 3 4 5 6 7 CN4002 1 2 3 CL3101 AL+3.3V GND KEY-IN1 CN3101 1 2 3 12-1 HDMICONNECTOR-1 CL3102 GND REMOTE AL+3.3V P-ON+5V LED1 KEY-IN1 LIGHT USB JACK CN4052 1 2 3 4 5 6 7 PC-RGB-IN CN3802 1 2 DIGITAL MAIN CBA UNIT SP(R) SP-GND HEADPHONE CL3802 AUDIO(R)-IN SP862 SPEAKER R-CH DIGITAL AUDIO-OUT (COAXIAL) CN3801 1 2 AUDIO(L)-IN SP(L) SP-GND COMPONENT -Pr-IN MAIN CBA CL301 VCOM-PWM BACKLIGHT-SW BACKLIGHT-ADJ PROTECT3 PROTECT1 P-ON-H1 P-ON-H2 RESET GND GND AL+5V GND AMP+11V AMP+11V GND P-ON+24V P-ON+24V GND GND COMPONENT -Pb-IN CL3801 IR SENSOR CBA UNIT CN601 1 2 CN301 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 COMPONENT-Y /VIDEO-IN SP861 SPEAKER L-CH FUNCTION CBA UNIT AC601 AC CORD CN3005 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 CL3005 STV XAO OE1 CPV POL TP GND LLV5(-) LLV5(+) LLV4(-) LLV4(+) LLV3(-) LLV3(+) GND LLVCLK(-) LLVCLK(+) GND LLV2(-) LLN2(+) LLV1(-) LLV1(+) LLV0(-) LLV0(+) GND CL201 GND PANEL+13V PANEL+13V PANEL+24V GND PANEL+3.3V PANEL+3.3V PANEL-7.1V GND VCOM GND LCD MODULE ASSEMBLY BACK LIGHT CN1002 1 2 CN201 1 2 3 4 5 6 7 8 9 10 11 BACK LIGHT CN1001 1 2 WIRING DIAGRAM [TYPE A] CN3701 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 TUNER UNIT FL11.0AWI CN302 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 CN301 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 CL3006 GND SPDIF GND VIDEO-IN S-VIDEO-SW S-VIDEO-C-IN GND S-VIDEO-Y-IN GND INPUT1 AUDIO(R) INPUT0 AUDIO(L) GND COM-VIDEO-Y-IN GND COM-VIDEO-Pb-IN GND COM-VIDEO-Pr-IN AUDIO-MUTE SDA SCL RESET IF-AGC GND DIF-OUT1 GND DIF-OUT2 KEY-IN1 CN3006 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 CL3002 CN3002 1 P-ON-H2 AUDI(L)-OUT(NU) 2 3 GND AUDI(R)-OUT(NU) 4 PROTECT3 5 AMP(L)-OUT 6 7 GND AMP(R)-OUT 8 P-ON-H1 9 10 P-ON+3V 11 PROTECT1 GND 12 LED-R 13 P-ON+5V 14 PROTECT2 15 P-ON+7V 16 GND 17 18 GND 19 P-ON+3.3V 20 P-ON+3.3V 21 AL+3.3V 22 AL+3.3V 23 GND 24 OE2 25 REMOTE BACKLIGHT-SW 26 27 LED1 BACKLIGHT-ADJ 28 VCOM-PWM 29 12-2 SP(R) SP-GND CL101 GND REMOTE AL+3.3V LED1 P-ON-H1 KEY-IN1 KEY-IN2 DVD-LED CN872 1 2 CN102 1 2 3 4 5 6 7 8 TUNER UNIT FUNCTION CBA CN101B 1 2 3 4 5 6 7 8 CL862 SP862 SPEAKER R-CH MAIN CBA DIGITAL MAIN CBA UNIT AC601 AC CORD CL201 GND PANEL+13V PANEL+13V PANEL+24.5V GND PANEL+3.3V PANEL+3.3V PANEL-7.1V GND VCOM GND CN702 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 CN871 1 2 JACK CBA CL701 CN701 SP(R) 1 SP(R) 2 HEADPHONE(R) 3 HEADPHONE(R) 4 GND 5 6 GND 7 GND 8 GND HEADPHONE(L) 9 HEADPHONE(L) 10 11 GND 12 GND 13 AUDIO(L) 14 P-ON+9V 15 AUDIO(R) COM-VIDEO-Pr-IN 16 17 GND COM-VIDEO-Pb-IN 18 19 S-VIDEO-SW COM-VIDEO-Y-IN 20 21 GND 22 INPUT0 23 SPDIF 24 INPUT1 25 GND S-VIDEO-Y-IN 26 27 VIDEO-IN S-VIDEO-C-IN 28 29 GND LCD MODULE ASSEMBLY BACK LIGHT CN1002 1 2 CN201 1 2 3 4 5 6 7 8 9 10 11 BACK LIGHT CN1001 1 2 SP(L) SP-GND DIGITAL AUDIO-OUT (COAXIAL) S-VIDEO -IN PC-AUDIO -IN AUDIO(R) -IN AUDIO(L) -IN VIDEO-IN HDMIAUDIO(R)-IN HDMIAUDIO(L)-IN COMPONENTAUDIO(R)-IN COMPONENTAUDIO(L)-IN COMPONENT -Pr-IN COMPONENT -Pb-IN CL861 CN3005 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 COMPONENT -Y-IN CL3005 STV XAO OE1 CPV POL TP GND LLV5(-) LLV5(+) LLV4(-) LLV4(+) LLV3(-) LLV3(+) GND LLVCLK(-) LLVCLK(+) GND LLV2(-) LLN2(+) LLV1(-) LLV1(+) LLV0(-) LLV0(+) GND SP861 SPEAKER L-CH USB JACK HDMICONNECTOR-2 HDMICONNECTOR-1 PC-RGB-IN [TYPE B] FL11.0BWI CN4101 1 2 CL3103 P-ON+5V GND CN3103 1 2 CN4052 1 2 3 4 5 6 7 CL3102 GND REMOTE AL+3.3V P-ON+5V LED1 KEY-IN1 LIGHT CN3102 1 2 3 4 5 6 7 12-3 HDMICONNECTOR-1 CN3802 1 2 USB JACK SP(R) SP-GND PC-RGB-IN CL3802 DIGITAL MAIN CBA UNIT SP3802 SPEAKER R-CH HEADPHONE CN3801 1 2 AUDIO(R)-IN SP(L) SP-GND DIGITAL AUDIO-OUT (COAXIAL) CL3801 AUDIO(L)-IN LED CBA UNIT SP3801 SPEAKER L-CH COMPONENT -Pr-IN CN4051 1 IR SENSOR 2 CBA UNIT 3 MAIN CBA CL601 VCOM-PWM(NU) BACKLIGHT-SW BACKLIGHT-ADJ PROTECT3 PROTECT1 P-ON-H1(NU) P-ON-H2 RESET GND GND AL+5V GND AMP+11V AMP+11V GND P-ON+21V P-ON+21V GND GND COMPONENT -Pb-IN CL4051 AL+3.3V GND KEY-IN1 CN603 1 2 CN601 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 COMPONENT-Y /VIDEO-IN CN4002 1 2 3 FUNCTION CBA UNIT AC601 AC CORD CN3006 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 CN1001 1 2 3 4 5 6 CL3006 STV XAO OE1 CPV POL TP GND LLV5(-) LLV5(+) LLV4(-) LLV4(+) LLV3(-) LLV3(+) GND LLVCLK(-) LLVCLK(+) GND LLV2(-) LLV2(+) LLV1(-) LLV1(+) LLV0(-) LLV0(+) GND P-ON+3.3V PWR-CTRL VCOM-PWM GND LCD+21V LCD+21V CL1001 ILED3 ILED2 ILED4 ILED1 NU VLED LCD MODULE ASSEMBLY [TYPE C] CN3701 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 TUNER UNIT FL11.0CWI EXPLODED VIEWS Cabinet [TYPE A] A1 Function CBA Unit CL3101 A15 A4 A42 CL3005 SP861 CL201 Digital Main CBA Unit S6 L1 L1 SP862 CL3801 L26 A8 B11 CL3802 L26 L24 B18 B11 L24 B9 CL3102 L12 A11 L26 IR Sensor CBA Unit L26 LCD1 B22 L26 L12 CL301 L15 X7 B22 L26 L1 B5 B34 L1 L17 Main CBA See Electrical Parts List for parts with this mark. B35 L26 S6 L25 AC601 L23 A12 A2 L15 L1 L1 S6 Stand Assembly L8 13-1 FL11.0-A_CEX Cabinet [TYPE B] Digital Main CBA Unit A42 A1 L12 B1 L4 CL3701 CL3702 L12 A10 A24 L3 B7 B44 B7 CL3902 Jack CBA CL201 A5 L4 L11 L3 L1 A9 SP861 L3 L1 A3 SP862 CL862 L8 L2 B3 B8 CL861 B8 L2 CL701 L3 Function CBA L8 L9 B3 A4 L3 LCD1 B2 B13 L1 B4 L1 L3 L4 S5 L3 Main CBA L13 See Electrical Parts List for parts with this mark. B14 L1 L5 AC601 L1 A8 A6 L9 S5 L1 Stand Assembly L17 13-2 FL11.0-B_CEX Cabinet [TYPE C] A1 B48 B48 A15 A42 Digital Main CBA Unit B48 CL3006 A8 B27 A10 X7 L14 CL3102 B18 Main CBA B32 CL601 CL3801 A11 SP3801 IR Sensor CBA Unit L14 B47 LCD1 L14 A40 CL4051 S6 LED CBA Unit Function CBA Unit CL3103 B22 L14 CL3802 B62 SP3802 B47 A2 CL1001 L3 L14 L14 AC601 B5 L25 See Electrical Parts List for parts with this mark. A12 L25 S6 L16 L16 S6 Stand Assembly L28 13-3 FL11.0-C_CEX Packing [TYPE A] L8 X6 X4 Stand Assembly X3 X2 Tape S7 S3 X1 S5 Packing Tape Tape S4 Packing Tape S6 FRO NT FRO NT S1 Some Ref. Numbers are not in sequence. 13-4 FL11.0(A17N5)-A_PEX Packing [TYPE B] L17 X4 X3 X6 X2 Tape Stand Assembly S6 X1 S2 S4 OPP Tape Packing Tape Tape X10 Packing Tape S3 FR ON T S3 S5 FR ON T Some Ref. Numbers are not in sequence. S1 13-5 FL11.0(A17N2)-B_PEX Packing [TYPE C] S3 X2 S5 X6 X3 X4 Packing Tape L28 Tape X1 S7 Packing Tape S4 FRO NT TO CARTON S6 Some Ref. Numbers are not in sequence. S1 13-6 FL11.0(A11N5)-C_PEX TYPE A PARTS LIST [19MF301B/F7 (Serial No.: TH1)] Mechanical Parts PRODUCT SAFETY NOTE: Products marked with a # have special characteristics important to safety. Before replacing any of these components, read carefully the product safety notice in this service manual. Don't degrade the safety of the product through improper servicing. Ref. No. Description STAND ASSEMBLY A17N5UT Part No. SET BAG A81N0UH 1EM323958A S6 SERIAL NO. LABEL A01PBUH ---------- S7 STAND BAG A81N0UH 1EM425888 ACCESSORIES NOTE: Parts that are not assigned part numbers (---------) are not available. Ref. No. Description S5 Part No. X1 BAG POLYETHYLENE 235X365XT0.03 0EM408420A X2# OWNERS MANUAL A17N7UT 1EMN27981 X3 REMOTE CONTROL NF805UD NF805UD X4 DRY BATTERY R03/2S XB0M451T0006 X6 QUICK START GUIDE A17N7UT 1EMN27982 X7 REGISTRATION CARD (MAGNAVOX) A17N7UT 1EMN27760 1ESA28285 A1 FRONT CABINET A17N0UH 1EM126293 A2 REAR CABINET A17N1UH 1EM026966 A4 FUNCTION KNOB A17N1UH 1EM225364 A8 JACK HOLDER A17N1UH 1EM225424 A11 SENSOR LENS A17N1UH 1EM329957 A12# RATING LABEL A17N7UT ---------- A15 ENERGY STAR LABEL A91F2UH ---------- A42 ENERGY GUIDE LABEL A17N7UT ---------- AC601# AC CORD W/O A GND WIRE UL/CSA/1700/NO/ WAC1720LW005 BLACK B5 STAND HOLDER A94N0UH 1EM325619 B9 SENSOR PLATE A17N1UH 1EM329958 B11 SPEAKER HOLDER A94N0UH 1EM325677 B18 GASKET A8AF0UH 1EM425861 B22 WALL MOUNT BRACKET A84N0UH 1EM323797 B35 GUARD HOLDER A17N1UH 1EM225524 CL201 WIRE ASSEMBLY 11PIN FFC 11PIN 80MM WX1A17N1-101 CL301 WIRE ASSEMBLY 19PIN FFC 19PIN 65MM WX1A17N1-102 CL3005 WIRE ASSEMBLY 24PIN FFC 24PIN 155MM WX1A17N1-123 CL3101 WIRE ASSEMBLY 3PIN 3PIN/150MM/RED BLACK WX1A17N1-212 CL3102 WIRE ASSEMBLY 7PIN 7PIN/360MM/RED BLACK WX1A17N1-201 CL3801 WIRE ASSEMBLY 2PIN 2PIN/120MM/RED BLACK WX1A17N1-321 CL3802 WIRE ASSEMBLY 2PIN 2PIN/355MM/RED BLACK WX1A17N1-312 L1 SCREW P-TIGHT 3X10 BIND HEAD+ GBHP3100 L8 STAND SCREW KIT A17N5UT 1ESA28286 L12 SCREW P-TIGHT M3X8 BIND HEAD+ GBJP3080 L15 DOUBLE SEMS SCREW M4X10 + BLK FPH34100 L23 SCREW TAP TIGHT M3X10 BIND HEAD+BLK NI GBHS3100 L24 ASSEMBLED SCREW M3X10 1EM420633A L25 S-TIGHT SCREW M3X6 BIND HEAD+BLACK GBHS3060 L26 SCREW S-TIGHT M3X8 BIND HEAD+ GBJS3080 LCD1 LCD MODULE 18.5INCH 18.5INCH WXGA UK19MXA SP861 SPEAKER S0307F03 DS08070XQ001 SP862 SPEAKER S0307F03 DS08070XQ001 PACKING S1 CARTON A17N7UT 1EM435126 S3 STYROFOAM TOP A17N5UT 1EM027907 S4 STYROFOAM BOTTOM A17N5UT 1EM027908 2011/05/11 14-1 A17N7CA.fm Electrical Parts PRODUCT SAFETY NOTE: Products marked with a # have special characteristics important to safety. Before replacing any of these components, read carefully the product safety notice in this service manual. Don't degrade the safety of the product through improper servicing. Ref. No. C640 NOTES: 1. Parts that are not assigned part numbers (---------) are not available. 2. Tolerance of Capacitors and Resistors are noted with the following symbols. C.....±0.25% D.....±0.5% F.....±1% G.....±2% J......±5% K.....±10% M.....±20% N.....±30% Z.....+80/-20% DIGITAL ASSEMBLY Ref. No. Description Part No. DIGITAL ASSEMBLY Consists of the following A17N7MMA-001 DIGITAL MAIN CBA UNIT FUNCTION CBA UNIT IR SENSOR CBA UNIT A17N7MMA-001-DM A17N7MMA-001-FN A17N7MMA-001-IR MAIN CBA Ref. No. Description MAIN CBA Consists of the following Part No. A17N5MPW-001 CAPACITORS Description ELECTROLYTIC CAP. 10µF/50V M Part No. CE1JMASDL100 C641 CHIP CERAMIC CAP.(1608) B K 0.1µF/16V CHD1CK30B104 C645 CHIP CERAMIC CAP. B K 2200pF/50V CHD1JK30B222 C647 ELECTROLYTIC CAP. 100µF/10V M CE1AMASDL101 C652 ELECTROLYTIC CAP. 100µF/10V M CE1AMASDL101 C661 ELECTROLYTIC CAP. 3.3µF/50V M CE1JMASDL3R3 C685 CHIP CERAMIC CAP.(1608) B K 0.1µF/50V CHD1JK30B104 C692# SAFTY CAP. 3300pF/250V KX CA2E332MR101 C695 ELECTROLYTIC CAP. 470µF/25V M CE1EMASDL471 C1001 CHIP CERAMIC CAP. B K 1200pF/50V CHD1JK30B122 C1002 CAP CHIP CERAMIC 0.01µF/250V CA2E103MR088 C1003 CHIP CERAMIC CAP.(1608) B K 0.01µF/50V CHD1JK30B103 C1004 CHIP CERAMIC CAP.(1608) B K 0.01µF/50V CHD1JK30B103 C1005 CAP CHIP CERAMIC 0.01µF/250V CA2E103MR088 C1006 CAP CERAMIC HV 10pF/6.3KV/SL/J CCA1000MR001 C1007 CHIP CERAMIC CAP. B K 1200pF/50V CHD1JK30B122 C1008 CAP CERAMIC HV 10pF/6.3KV/SL/J CCA1000MR001 C1009 ELECTROLYTIC CAP. 10µF/50V M CE1JMASDL100 C1010 ELECTROLYTIC CAP. 10µF/50V M CE1JMASDL100 C1011 ELECTROLYTIC CAP. 1000µF/35V M CE1GMZPDL102 C1014 CAP CERAMIC HV 10pF/6.3KV/SL/J CCA1000MR001 C1015 CAP CERAMIC HV 10pF/6.3KV/SL/J CCA1000MR001 C1016 CHIP CERAMIC CAP.(1608) B K 6800pF/50V CHD1JK30B682 C1018 CHIP CERAMIC CAP.(1608) F Z 0.1µF/50V CHD1JZ30F104 C1020 CHIP CERAMIC CAP.(1608) F Z 0.1µF/50V CHD1JZ30F104 C1022 ELECTROLYTIC CAP. 100µF/16V M CE1CMASDL101 C1023 CAP CHIP CERAMIC 0.01µF/250V CA2E103MR088 C1024 CHIP CERAMIC CAP.(1608) B K 0.01µF/50V CHD1JK30B103 C1025 CHIP CERAMIC CAP.(1608) B K 0.01µF/50V CHD1JK30B103 C1026 CHIP CERAMIC CAP.(1608) B K 0.1µF/50V CHD1JK30B104 C1027 ELECTROLYTIC CAP. 10µF/50V M CE1JMASDL100 C1028 CHIP CERAMIC CAP.(1608) B K 0.01µF/50V CHD1JK30B103 CE1EMASDL471 C1029 CAP CHIP CERAMIC 0.01µF/250V CA2E103MR088 CHIP CERAMIC CAP.(1608) B K 0.1µF/50V CHD1JK30B104 C1030 CHIP CERAMIC CAP.(1608) B K 1000pF/50V CHD1JK30B102 ELECTROLYTIC CAP. 4.7µF/50V M CE1JMASDL4R7 C1031 CHIP CERAMIC CAP.(1608) CH J 1000pF/50V CHD1JJ3CH102 C201 ELECTROLYTIC CAP. 470µF/25V M C203 C204 C205 ELECTROLYTIC CAP. 22µF/50V M CE1JMASDL220 C1032 CHIP CERAMIC CAP.(1608) B K 0.01µF/50V CHD1JK30B103 C207 ELECTROLYTIC CAP. 10µF/50V M CE1JMASDL100 C1033 ELECTROLYTIC CAP. 10µF/50V M CE1JMASDL100 CHD1JK30B103 C208 CHIP CERAMIC CAP.(1608) B K 0.1µF/50V CHD1JK30B104 C1034 CHIP CERAMIC CAP.(1608) B K 0.01µF/50V C209 ELECTROLYTIC CAP. 47µF/25V M CE1EMASDL470 C1035 CHIP CERAMIC CAP.(1608) B K 0.01µF/50V CHD1JK30B103 C212 ELECTROLYTIC CAP. 100µF/25V M CE1EMASDL101 C1037 CHIP CERAMIC CAP. (1608) B K 1µF/16V CHD1CK30B105 C214 CHIP CERAMIC CAP.(1608) CH J 1000pF/50V CHD1JJ3CH102 C1038 CHIP CERAMIC CAP.(1608) B K 0.1µF/50V CHD1JK30B104 C215 CHIP CERAMIC CAP.(1608) F Z 0.1µF/50V CHD1JZ30F104 C1039 CHIP CERAMIC CAP.(1608) B K 0.01µF/50V CHD1JK30B103 C216 CHIP CERAMIC CAP. (1608) B K 1µF/16V CHD1CK30B105 C1040 CHIP CERAMIC CAP.(1608) B K 1000pF/50V CHD1JK30B102 CHD1JK30B103 C217 ELECTROLYTIC CAP. 47µF/25V M CE1EMASDL470 C1041 CHIP CERAMIC CAP.(1608) B K 0.01µF/50V C218 CHIP CERAMIC CAP.(1608) F Z 0.1µF/50V CHD1JZ30F104 C1042 CHIP CERAMIC CAP.(1608) F Z 0.1µF/50V CHD1JZ30F104 C401 ELECTROLYTIC CAP. 1µF/50V M CE1JMASDL1R0 C1043 CHIP CERAMIC CAP.(1608) B K 0.22µF/16V CHD1CK30B224 C601# CAP METALIZED FILM 0.47µF/300V K 3.5MM CT2F474DC004 C1044 CHIP CERAMIC CAP.(1608) B K 0.1µF/50V CHD1JK30B104 C602 CHIP CERAMIC CAP. B K 1800pF/50V CHD1JK30B182 C1045 CHIP CERAMIC CAP.(1608) B K 0.1µF/16V CHD1CK30B104 C603 CAP ELECTROLYTIC 220µF/200V CEA221DYG005 C1046 CHIP CERAMIC CAP.(1608) B K 1000pF/50V CHD1JK30B102 C604 CHIP CERAMIC CAP. B K 0.039µF/50V CHD1JK30B393 C1053 ELECTROLYTIC CAP. 100µF/16V M CE1CMASDL101 C605 CHIP CER. BK 0.082µF/50V CHD1JK30B823 C1054 CHIP CERAMIC CAP.(1608) F Z 0.1µF/50V CHD1JZ30F104 C606 CHIP CERAMIC CAP. B K 1800pF/50V CHD1JK30B182 C1056 CHIP CERAMIC CAP.(1608) B K 0.1µF/50V CHD1JK30B104 C607 CERAMIC CAP. 560pF/2KV CA3D561PAN04 C631 ELECTROLYTIC CAP. 470µF/25V M CE1EMASDL471 CN201 FFC CONNECTOR IMSA-9615S-11A-PP-A C632 ELECTROLYTIC CAP. 1000µF/35V M CE1GMZPDL102 CN301 C633 CERAMIC CAP. B K 1500pF/1KV CCD3AKN0B152 FMN CONNECTOR TOP 19P IMSA-9615S-19A- JC96J19ER007 PP-A C634 CHIP CERAMIC CAP.(1608) B K 0.1µF/16V CHD1CK30B104 CN601# CONNECTOR S2P3-VH (LF)(SN) C636 ELECTROLYTIC CAP. 100µF/25V M CE1EMASDL101 CN1001# CONNECTOR PRINT OSU KW05-120-02-00 J30502KET001 C637 CHIP CERAMIC CAP.(1608) B K 0.1µF/16V CHD1CK30B104 CN1002# CONNECTOR PRINT OSU KW05-120-02-00 J30502KET001 C639 ELECTROLYTIC CAP. 100µF/10V M CE1AMASDL101 2011/05/11 CONNECTORS 14-2 JC96J11ER007 JCVHC02JG002 A17N7EL.fm Ref. No. Description Ref. No. Part No. D1029 DIODES Description DIODE ZENER 12BSB-T26 Part No. NDTB012BST26 D201 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 D1030 DIODE ZENER 12BSB-T26 NDTB012BST26 D204 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 D1031 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 D207 DIODE ZENER 7V5BSA-T26 NDTA7R5BST26 D1034 DIODE ZENER 11BSB-T26 NDTB011BST26 D401 DIODE SK16-T/R ND1Z0000SK16 D1036 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 D402 DIODE ZENER 8V2BSB-T26 NDTB8R2BST26 D1038 WIRE CP STP-S-0.50 XZ40F0REN001 D404 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 D1045 SWITCHING DIODE 1SS133(T-77) D405 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 D406 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 IC201 IC TL3472CDR NSZBA0TTY115 D409 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 IC202 IC(REGULATOR) PQ200WNA1ZPH QSZBA0TSH072 D416 DIODE ZENER 10BSB-T26 NDTB010BST26 IC601# IC PHOTOCOUPLER TLP781F(D4-FUNBLL F) QPEL781FBLLF D417 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 IC631 IC(REGULATOR) PQ200WNA1ZPH QSZBA0TSH072 IC1001 IC PULSE-WIDTH-MODULATION CONT TL494CDR NSCA0T0TY006 IC1002 IC OPERATIONNAL AMPLIFIER KIA358F-EL NSZBA0TJY030 D418 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 D601# DIODE 1N5397BD NDL1001N5397 D602# DIODE 1N5397BD NDL1001N5397 QDTZ001SS133 ICS COIL D603# DIODE 1N5397BD NDL1001N5397 D604# DIODE 1N5397BD NDL1001N5397 D605 DIODE ZENER 4V3BSB-T26 NDTB4R3BST26 D607# DIODE ZENER 27BSB-T26 NDTB027BST26 Q202 CHIP TRANSISTOR 2SA1037AK T146R QQ1R2SA1037A D608# SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 Q203 CHIP TRANSISTOR 2SC2412K T146S QQ1S2SC2412K CHIP TRANSISTOR 2SC2412K T146S QQ1S2SC2412K TRANSISTOR 2SC2655-Y(TE6 F M) QQSY2SC2655F NQVYKTA1281P L601# LINE FILTER 5.0MH 96005 LLBG00ZKT004 TRANSISTORS D609 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 Q206 D610 DIODE ZENER 1ZB220-YBB NDWZ01ZB220Y Q207 D615# DIODE ZENER 1ZB36BB NDWZ0001ZB36 Q208 TRANSISTOR KTA1281-Y-AT/P D631 DIODE SCHOTTKY SMD SK2B-TR ND1Z00SK2BTR Q209 CHIP TRANSISTOR 2SC2412K T146S QQ1S2SC2412K CHIP TRANSISTOR 2SA1037AK T146R QQ1R2SA1037A D632 DIODE SCHOTTKY SB3150BH NDWZ00SB3150 Q211 D633# DIODE ZENER 1ZB30BB NDWZ0001ZB30 Q212 CHIP TRANSISTOR 2SC2412K T146S QQ1S2SC2412K D634 DIODE ZENER 5V6BSB-T26 NDTB5R6BST26 Q400 CHIP TRANSISTOR 2SC2412K T146S QQ1S2SC2412K D636 DIODE SK16-T/R ND1Z0000SK16 Q401 CHIP TRANSISTOR 2SC2412K T146S QQ1S2SC2412K CHIP TRANSISTOR 2SC2412K T146S QQ1S2SC2412K FET MOS TK5A50D(FUNAI QEWZTK5A50DQ D639 DIODE SK16-T/R ND1Z0000SK16 Q402 D642 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 Q601# D648 DIODE ZENER 5V6BSB-T26 NDTB5R6BST26 Q602# TRANSISTOR 2SC2120-Y(TE2 F T) QQSY2SC2120F D649 DIODE ZENER 3V3BSB-T26 NDTB3R3BST26 Q631 CHIP TRANSISTOR 2SC2412K T146S QQ1S2SC2412K CHIP TRANSISTOR 2SC2412K T146S QQ1S2SC2412K NQSYKTC3198P D650 DIODE ZENER 5V6BSB-T26 NDTB5R6BST26 Q633 D651 WIRE CP STP-S-0.50 XZ40F0REN001 Q634 TRANSISTOR KTC3198-Y-AT/P D655 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 Q638 CHIP TRANSISTOR 2SC2412K T146S QQ1S2SC2412K D656 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 Q639 PNP TRANSISTOR SMD 2SA1576UBTLQ QQ1Q2SA1576U D657 DIODE ZENER 1ZB7.5BB NDWZ001ZB7R5 Q641 CHIP TRANSISTOR 2SC2412K T146S QQ1S2SC2412K D668# DIODE ZENER 1ZB22BB NDWZ0001ZB22 Q1001 CHIP TRANSISTOR 2SC2412K T146S QQ1S2SC2412K D670 DIODE SCHOTTKY SMD SK2B-TR ND1Z00SK2BTR Q1002 CHIP TRANSISTOR 2SC2412K T146S QQ1S2SC2412K D671# DIODE ZENER 1ZB20BB NDWZ0001ZB20 Q1003 CHIP TRANSISTOR 2SC2412K T146S QQ1S2SC2412K CHIP TRANSISTOR 2SC2412K T146S QQ1S2SC2412K D672 DIODE SK16-T/R ND1Z0000SK16 Q1004 D1001 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 Q1005# FET MOS SMD TPC8214-H QF2ZTPC8214H D1002 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 Q1006 CHIP TRANSISTOR 2SA1037AK T146R QQ1R2SA1037A D1003 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 Q1007 CHIP TRANSISTOR 2SA1037AK T146R QQ1R2SA1037A CHIP TRANSISTOR 2SC2412K T146S QQ1S2SC2412K D1004 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 Q1008 D1005 DIODE ZENER 6V2BSB-T26 NDTB6R2BST26 Q1009 CHIP TRANSISTOR 2SC2412K T146S QQ1S2SC2412K D1006 SWITCHING DIODE DAP202UT106 QD1Z0DAP202U Q1010 CHIP TRANSISTOR 2SC2412K T146S QQ1S2SC2412K D1009 SWITCHING DIODE DAN202U T106 QD1Z0DAN202U Q1011 TRANSISTOR 2SA950-Y(TE2 F T) QQSY02SA950F CHIP TRANSISTOR 2SC2412K T146S QQ1S2SC2412K D1010 SWITCHING DIODE DAP202UT106 QD1Z0DAP202U Q1012 D1011 SWITCHING DIODE DAP202UT106 QD1Z0DAP202U Q1014 CHIP TRANSISTOR 2SC2412K T146S QQ1S2SC2412K D1013 SWITCHING DIODE DAP202UT106 QD1Z0DAP202U Q1015 CHIP TRANSISTOR 2SC2412K T146S QQ1S2SC2412K D1015 SWITCHING DIODE DAP202UT106 QD1Z0DAP202U Q1016 CHIP TRANSISTOR 2SC2412K T146S QQ1S2SC2412K CHIP TRANSISTOR 2SC2412K T146S QQ1S2SC2412K D1016 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 Q1017 D1017 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 Q1018 CHIP TRANSISTOR 2SA1037AK T146R QQ1R2SA1037A D1018 DIODE ZENER 6V8BSB-T26 NDTB6R8BST26 Q1019 CHIP TRANSISTOR 2SC2412K T146S QQ1S2SC2412K D1020 DIODE ZENER 5V1BSB-T26 NDTB5R1BST26 Q1023 CHIP TRANSISTOR 2SC2412K T146S QQ1S2SC2412K Q1024 CHIP TRANSISTOR 2SA1037AK T146R QQ1R2SA1037A D1021 DIODE ZENER 15BSB-T26 NDTB015BST26 D1022 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 D1023 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 R201 WIRE CP STP-S-0.50 XZ40F0REN001 D1024 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 R202 RES CHIP 1608 1/10W F 8.2k Ω RTW8201HH008 D1025 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 R203 RES CHIP 1608 1/10W F 680 Ω RTW6800HH008 D1028# DIODE ZENER 4V7BSB-T26 NDTB4R7BST26 R204 RES CHIP 1608 1/10W F 2.2k Ω RTW2201HH008 R205 RES CHIP 1608 1/10W J 22k Ω RRXA223HH013 2011/05/11 RESISTORS 14-3 A17N7EL.fm Ref. No. Description Part No. Ref. No. Description Part No. R209 RES CHIP 1608 1/10W J 56k Ω RRXA563HH013 R642 RES CHIP 1608 1/10W F 27.0k Ω R210 RES CHIP 1608 1/10W J 6.8k Ω RRXA682HH013 R643 RES CHIP 1608 1/10W F 27.0k Ω RTW2702HH008 R211 RES CHIP 1608 1/10W J 47k Ω RRXA473HH013 R646 RES CHIP 1608 1/10W F 2.2k Ω RTW2201HH008 R212 RES CHIP 1608 1/10W J 10k Ω RRXA103HH013 R647 RES CHIP 1608 1/10W J 47k Ω RRXA473HH013 R213 RES CHIP 1608 1/10W J 27k Ω RRXA273HH013 R648 RES CHIP 1608 1/10W J 10k Ω RRXA103HH013 R214 RES CHIP 1608 1/10W J 22k Ω RRXA223HH013 R649 RES CARBON FILM T 1/4W J 220 Ω RCX4221T1001 R220 RES CHIP 1608 1/10W J 47k Ω RRXA473HH013 R650 RES CARBON FILM T 1/4W J 220 Ω RCX4221T1001 R221 RES CHIP 1608 1/10W J 22k Ω RRXA223HH013 R651 RES CARBON FILM T 1/4W J 10 Ω RCX4100T1001 R222 RES CARBON FILM T 1/4W J 180 Ω RCX4181T1001 R652 WIRE CP STP-S-0.50 XZ40F0REN001 R223 RES CHIP 1608 1/10W J 15k Ω RRXA153HH013 R653 RES CHIP 1608 1/10W F 330 Ω RTW3300HH008 R224 RES CHIP 1608 1/10W J 1.0 Ω RRXA1R0HH013 R655 RES CHIP 1608 1/10W F 240 Ω RTW2400HH008 R225 RES CHIP 1608 1/10W 0 Ω RRXA000HH014 R656 RES CARBON FILM T 1/4W J 220 Ω RCX4221T1001 R226 RES CARBON FILM T 1/4W J 10 Ω RCX4100T1001 R661 RES CARBON FILM T 1/4W J 220 Ω RCX4221T1001 R227 RES CHIP 1608 1/10W J 100k Ω RRXA104HH013 R662 RES CARBON FILM T 1/4W J 15k Ω RCX4153T1001 R228 WIRE CP STP-S-0.50 XZ40F0REN001 R666 RES CHIP 1608 1/10W J 22k Ω RRXA223HH013 R229 RES CARBON FILM T 1/4W J 10 Ω RCX4100T1001 R667 RES CHIP 1608 1/10W J 1.0k Ω RRXA102HH013 R230 RES CHIP 1608 1/10W J 10k Ω RRXA103HH013 R668 RES CHIP 1608 1/10W J 47k Ω RRXA473HH013 R231 RES CHIP 1608 1/10W J 1.5k Ω RRXA152HH013 R669 RES CHIP 1608 1/10W J 10k Ω RRXA103HH013 R232 RES CHIP 1608 1/10W J 15k Ω RRXA153HH013 R670 RES CHIP 1608 1/10W J 4.7k Ω RRXA472HH013 R233 RES CHIP 1608 1/10W J 10k Ω RRXA103HH013 R677 RES CHIP 1608 1/10W 0 Ω RRXA000HH014 R234 RES CHIP 1608 1/10W J 1.0k Ω RRXA102HH013 R682 WIRE CP STP-S-0.50 XZ40F0REN001 R235 RES CARBON FILM T 1/4W J 8.2k Ω RCX4822T1001 R1001 RES CARBON FILM T 1/4W J 2.2k Ω RCX4222T1001 R236 RES CHIP 1608 1/10W J 4.7k Ω RRXA472HH013 R1002 RES CARBON FILM T 1/4W J 180 Ω RCX4181T1001 R243 RES CARBON FILM T 1/4W J 180 Ω RCX4181T1001 R1003 RES CARBON FILM T 1/4W J 2.2k Ω RCX4222T1001 R244 RES CHIP 1608 1/10W J 22k Ω RRXA223HH013 R1004 RES CHIP 1608 1/10W J 10k Ω RRXA103HH013 R245 RES CHIP 1608 1/10W J 27k Ω RRXA273HH013 R1005 RES CHIP 1608 1/10W J 22k Ω RRXA223HH013 R246 RES CHIP 1608 1/10W J 47k Ω RRXA473HH013 R1006 RES CARBON FILM T 1/4W J 180 Ω RCX4181T1001 R247 RES CHIP 1608 1/10W J 10k Ω RRXA103HH013 R1007 RES CARBON FILM T 1/4W J 10 Ω RCX4100T1001 R401 RES CHIP 1608 1/10W J 1.0 Ω RRXA1R0HH013 R1008 RES CARBON FILM T 1/4W J 12k Ω RCX4123T1001 R402 RES CHIP 1608 1/10W F 9.10k Ω RTW9101HH008 R1009 RES CHIP 1608 1/10W J 1.0k Ω RRXA102HH013 R403 RES CHIP 1608 1/10W F 47.0k Ω RTW4702HH008 R1010 RES CARBON FILM T 1/4W J 10 Ω RCX4100T1001 R406 RES CHIP 1608 1/10W J 100k Ω RRXA104HH013 R1011 RES CARBON FILM T 1/4W J 12k Ω RCX4123T1001 R407 RES CHIP 1608 1/10W J 47k Ω RRXA473HH013 R1012 RES CHIP 1608 1/10W J 27k Ω RRXA273HH013 R408 RES CHIP 1608 1/10W J 47k Ω RRXA473HH013 R1013 RES CARBON FILM T 1/4W J 12k Ω RCX4123T1001 R413 RES CHIP 1608 1/10W J 22k Ω RRXA223HH013 R1014 RES CHIP 1608 1/10W J 27k Ω RRXA273HH013 R414 RES CHIP 1608 1/10W J 22k Ω RRXA223HH013 R1015 RES CHIP 1608 1/10W J 10k Ω RRXA103HH013 R415 RES CHIP 1608 1/10W J 6.8k Ω RRXA682HH013 R1017 RES CARBON FILM T 1/4W J 12k Ω RCX4123T1001 R416 RES CHIP 1608 1/10W J 2.7k Ω RRXA272HH013 R1018 RES CHIP 1608 1/10W J 390 Ω RRXA391HH013 R417 RES CHIP 1608 1/10W J 27k Ω RRXA273HH013 R1019 RES CHIP 1608 1/10W J 390 Ω RRXA391HH013 R418 RES CHIP 1608 1/10W J 4.7k Ω RRXA472HH013 R1020 RES CHIP 1608 1/10W J 1.0k Ω RRXA102HH013 R601# GLASS GLAZE RES. 1/2W J 2.7M Ω RXX2JZLZ0275 R1022 RES CHIP 1608 1/10W J 33k Ω RRXA333HH013 R602 CEMENT RES. 3W K 1.2 Ω RW031R2PG007 R1023 RES CHIP 1608 1/10W J 10k Ω RRXA103HH013 R603 RES CHIP 3216 1/4W J 390k Ω RRX4394HH034 R1024 RES CHIP 1608 1/10W F 22.0k Ω RTW2202HH008 R604 RES CHIP 3216 1/4W J 390k Ω RRX4394HH034 R1025 RES CHIP 1608 1/10W J 1.5k Ω RRXA152HH013 R605 RES CHIP 3216 1/4W J 390k Ω RRX4394HH034 R1026 RES CARBON FILM T 1/4W J 2.2k Ω RCX4222T1001 R606 RES CHIP 3216 1/4W J 330k Ω RRX4334HH034 R1027 RES CHIP 1608 1/10W J 5.1k Ω RRXA512HH013 R607 RES CARBON FILM T 1/4W J 150 Ω RCX4151T1001 R1028 RES CHIP 1608 1/10W J 1.0k Ω RRXA102HH013 R608 RES CARBON FILM T 1/4W J 150 Ω RCX4151T1001 R1029 RES CARBON FILM T 1/4W J 1.8k Ω RCX4182T1001 R609 RES CARBON FILM T 1/4W J 1.5k Ω RCX4152T1001 R1030 RES CARBON FILM T 1/4W J 20k Ω RCX4203T1001 R610 RES CARBON FILM T 1/4W J 2.2k Ω RCX4222T1001 R1031 RES CARBON FILM T 1/4W J 4.7k Ω RCX4472T1001 R611 RES CARBON FILM T 1/4W J 220 Ω RCX4221T1001 R1032# METAL OXIDE FILM RES. 2W J 0.33 Ω RN02R33ZU001 R612 RES CARBON FILM T 1/4W J 120 Ω RCX4121T1001 R1034 RES CHIP 1608 1/10W J 33k Ω RRXA333HH013 R613# METAL RESISTER. 2W J 0.56 Ω RN02R56ZU001 R1035 RES CHIP 1608 1/10W F 1.00k Ω RTW1001HH008 R614 RES CARBON FILM T 1/4W J 120 Ω RCX4121T1001 R1036 RES CHIP 1608 1/10W F 15.0k Ω RTW1502HH008 R631 RES CHIP 1608 1/10W J 12k Ω RRXA123HH013 R1037 RES CHIP 1608 1/10W 0 Ω RRXA000HH014 R632 WIRE CP STP-S-0.50 XZ40F0REN001 R1038 RES CHIP 1608 1/10W J 240k Ω RRXA244HH013 R633 RES CHIP 1608 1/10W J 47k Ω RRXA473HH013 R1039 RES CHIP 1608 1/10W F 68.0k Ω RTW6802HH008 R635 RES CHIP 1608 1/10W J 47k Ω RRXA473HH013 R1040 RES CHIP 1608 1/10W F 6.20k Ω RTW6201HH008 R636 RES CHIP 1608 1/10W J 10k Ω RRXA103HH013 R1041 RES CHIP 1608 1/10W F 1.00k Ω RTW1001HH008 R638 RES CARBON FILM T 1/4W J 3.9k Ω RCX4392T1001 R1042 RES CHIP 1608 1/10W J 22k Ω RRXA223HH013 R639 RES CHIP 1608 1/10W J 18k Ω RRXA183HH013 R1043 RES CHIP 1608 1/10W F 5.10k Ω RTW5101HH008 R640 RES CHIP 1608 1/10W F 18.0k Ω RTW1802HH008 R1044 RES CHIP 1608 1/10W F 5.10k Ω RTW5101HH008 R641 RES CHIP 1608 1/10W F 1.10k Ω RTW1101HH008 R1045 RES CHIP 1608 1/10W J 240k Ω RRXA244HH013 2011/05/11 14-4 RTW2702HH008 A17N7EL.fm Ref. No. Description Part No. R1046 RES CHIP 1608 1/10W J 24k Ω RRXA243HH013 R1048 RES CHIP 1608 1/10W J 22k Ω RRXA223HH013 R1049 RES CHIP 1608 1/10W J 12k Ω RRXA123HH013 R1050 RES CHIP 1608 1/10W J 390k Ω RRXA394HH013 R1051 RES CHIP 1608 1/10W J 390k Ω RRXA394HH013 R1052 RES CHIP 1608 1/10W F 100k Ω RTW1003HH008 R1054 RES CHIP 1608 1/10W F 13.0k Ω RTW1302HH008 R1055 RES CHIP 1608 1/10W F 220k Ω RTW2203HH008 R1056 RES CHIP 1608 1/10W F 30.0k Ω RTW3002HH008 R1057 RES CHIP 1608 1/10W J 390k Ω RRXA394HH013 R1058 RES CHIP 1608 1/10W F 10.0k Ω RTW1002HH008 R1059 RES CHIP 1608 1/10W F 10.0k Ω RTW1002HH008 R1060 RES CHIP 1608 1/10W J 10k Ω RRXA103HH013 R1061 RES CHIP 1608 1/10W J 33k Ω RRXA333HH013 R1065 RES CARBON FILM T 1/4W J 2.7k Ω RCX4272T1001 R1066 RES CARBON FILM T 1/4W J 2.7k Ω RCX4272T1001 R1067 RES CHIP 1608 1/10W J 1.0k Ω RRXA102HH013 R1068 RES CHIP 1608 1/10W J 1.0k Ω RRXA102HH013 R1069 RES CHIP 1608 1/10W J 1.0k Ω RRXA102HH013 R1070 RES CHIP 1608 1/10W J 1.0k Ω RRXA102HH013 R1071 RES CHIP 1608 1/10W F 4.30k Ω RTW4301HH008 R1072 RES CHIP 1608 1/10W F 270 Ω RTW2700HH008 R1073 RES CHIP 1608 1/10W F 1.20k Ω RTW1201HH008 R1074 RES CHIP 1608 1/10W J 100k Ω RRXA104HH013 R1081 RES CHIP 1608 1/10W F 100k Ω RTW1003HH008 R1082 RES CHIP 1608 1/10W F 68.0k Ω RTW6802HH008 R1083 RES CHIP 1608 1/10W F 1.00M Ω RTW1004HH008 R1084 RES CHIP 1608 1/10W J 100k Ω RRXA104HH013 R1086 RES CHIP 1608 1/10W F 100k Ω RTW1003HH008 R1087 RES CHIP 1608 1/10W F 68.0k Ω RTW6802HH008 R1088 RES CHIP 1608 1/10W F 1.00M Ω RTW1004HH008 R1089 RES CHIP 1608 1/10W F 12.0k Ω RTW1202HH008 R1090 RES CHIP 1608 1/10W F 47.0k Ω RTW4702HH008 R1091 RES CARBON FILM T 1/4W J 12k Ω RCX4123T1001 R1092 RES CARBON FILM T 1/4W J 12k Ω RCX4123T1001 R1093 RES CARBON FILM T 1/4W J 12k Ω RCX4123T1001 R1094 RES CARBON FILM T 1/4W J 12k Ω RCX4123T1001 R1095 RES CHIP 1608 1/10W J 1.2k Ω RRXA122HH013 R1099 RES CHIP 1608 1/10W J 1.0k Ω RRXA102HH013 R1105 RES CHIP 1608 1/10W J 3.3k Ω RRXA332HH013 R1106 RES CHIP 1608 1/10W J 10k Ω RRXA103HH013 R1107 RES CHIP 1608 1/10W J 10k Ω RRXA103HH013 R1109 RES CHIP 1608 1/10W F 2.20k Ω RTW2201HH008 R1110 RES CHIP 1608 1/10W J 10k Ω RRXA103HH013 R1111 RES CHIP 1608 1/10W J 10k Ω RRXA103HH013 R1112 RES CHIP 1608 1/10W 0 Ω RRXA000HH014 B34 POW HEAT SINK A7120UH 1EM423993 BC601 BEADS INDUCTOR FBR07HA121SB-00 LLBF00STU030 BC1001 BEADS INDUCTOR FBR07HA121SB-00 LLBF00STU030 BC1002 BEADS INDUCTOR FBR07HA121SB-00 LLBF00STU030 BC1003 BEADS INDUCTOR FBR07HA121SB-00 LLBF00STU030 F601# FUSE STC4A125V U/CT PAGE20CW3402 FH601 FUSE HOLDER MSF-015 LF (B110) XH01Z00LY002 FH602 FUSE HOLDER MSF-015 LF (B110) XH01Z00LY002 JS631 WIRE CP STP-S-0.50 XZ40F0REN001 L17 SCREW B-TIGHT D3X8 BIND HEAD+ GBJB3080 SA601# SURGE ABSORBER 470V+-10PER NVQZ10D471KB T631# TRANS POWER 11711 LTT2PC0KT072 T1002# TRANS INV HVT-323 LTZ3PZ0XB016 MISCELLANEOUS 2011/05/11 14-5 A17N7EL.fm TYPE A PARTS LIST [LC190EM2 (Serial No.: TH1)] Mechanical Parts PRODUCT SAFETY NOTE: Products marked with a # have special characteristics important to safety. Before replacing any of these components, read carefully the product safety notice in this service manual. Don't degrade the safety of the product through improper servicing. NOTE: Parts that are not assigned part numbers (---------) are not available. Different parts from the original model 19MF301B/F7 (Serial No. : TH1) Ref. No. A1 Description Part No. FRONT CABINET A17N1UH 1EM026965 ---------- A12# RATING LABEL A17N5UT A42 ENERGY GUIDE LABEL A17N5UT ---------- S1 CARTON A17N5UT 1EM435040 X2# OWNERS MANUAL A17N5UT 1EMN27859 X3 REMOTE CONTROL NH001UD NH001UD X6 QUICK START GUIDE A17N5UT 1EMN27860 X7 REGISTRATION CARD (EMERSON) A17N5UT 1EMN27764 2011/05/11 14-6 A17N5CA.fm Electrical Parts PRODUCT SAFETY NOTE: Products marked with a # have special characteristics important to safety. Before replacing any of these components, read carefully the product safety notice in this service manual. Don't degrade the safety of the product through improper servicing. Ref. No. Description Part No. You cannot mix components under Type 1 with the ones under Type 2. Type 1: (“78R000ZF” is engraved on Type 1 IC REGULATOR.) IC631 IC REGULATOR KIA78R000ZF-RTF/P NSCA0T0JY016 R646 RES CHIP 1608 1/10W F 1k Ω RTW1001HH008 R653 RES CHIP 1608 1/10W F1.4k Ω RTW1401HH008 NOTES: 1. Parts that are not assigned part numbers (---------) are not available. ←Make sure to use this IC631 with R646 (1k Ω) and R653 (1.4k Ω). 2. Tolerance of Capacitors and Resistors are noted with the following symbols. C.....±0.25% D.....±0.5% F.....±1% G.....±2% J......±5% K.....±10% M.....±20% N.....±30% or Type 2: (“200WNA1” is engraved on Type 2 IC REGULATOR.) Z.....+80/-20% Description IC(REGULATOR) PQ200WNA1ZPH R646 RES CHIP 1608 1/10W F 2.2k Ω QSZBA0TSH072 RTW2201HH008 R653 RES CHIP 1608 1/10W F 330 Ω RTW3300HH008 ←Make sure to use this IC631with R646 (2.2k Ω) Different parts from the original model 19MF301B/F7 (Serial No. : TH1) Ref. No. IC631 and R653 (330 Ω). Part No. DIGITAL ASSEMBLY Consists of the following A17N5MMA-001 DIGITAL MAIN CBA UNIT FUNCTION CBA UNIT IR SENSOR CBA UNIT A17N5MMA-001-DM A17N5MMA-001-FN A17N5MMA-001-IR MAIN CBA You cannot mix components under Type 1 with the ones under Type 2. Type 1: (“78R000ZF” is engraved on Type 1 IC REGULATOR.) IC202 IC REGULATOR KIA78R000ZF-RTF/P R202 RES CHIP 1608 1/10W F 9.1k Ω NSCA0T0JY016 RTW9101HH008 R203 RES CHIP 1608 1/10W F 510 Ω RTW5100HH008 R204 RES CHIP 1608 1/10W F 1k Ω RTW1001HH008 ←Make sure to use this IC202 with R202 (9.1k Ω) and R203 (510 Ω) and R204 (1k Ω). or Type 2: (“200WNA1” is engraved on Type 2 IC REGULATOR.) IC202 IC(REGULATOR) PQ200WNA1ZPH QSZBA0TSH072 R202 RES CHIP 1608 1/10W F 8.2k Ω RTW8201HH008 R203 RES CHIP 1608 1/10W F 680 Ω RTW6800HH008 R204 RES CHIP 1608 1/10W F 2.2k Ω RTW2201HH008 ←Make sure to use this IC202 with R202 (8.2k Ω) and R203 (680 Ω) and R204 (2.2k Ω). 2011/05/11 14-7 A17N5EL.fm TYPE A PARTS LIST [LC190EM2 (Serial No.: TH2)] Mechanical Parts PRODUCT SAFETY NOTE: Products marked with a # have special characteristics important to safety. Before replacing any of these components, read carefully the product safety notice in this service manual. Don't degrade the safety of the product through improper servicing. NOTE: Parts that are not assigned part numbers (---------) are not available. Different parts from the original model 19MF301B/F7 (Serial No. : TH1) Ref. No. A1 Description Part No. FRONT CABINET A17N1UH 1EM026965 ---------- A12# RATING LABEL A17N5UT A42 ENERGY GUIDE LABEL A17N5UT ---------- LCD1 LCD MODULE 18.5INCH WIDE CPT 18.5INCH WXGA UK19PXB S1 CARTON A17N5UT 1EM435040 X2# OWNERS MANUAL A17N5UT 1EMN27859 X3 REMOTE CONTROL NH001UD NH001UD X6 QUICK START GUIDE A17N5UT 1EMN27860 X7 REGISTRATION CARD (EMERSON) A17N5UT 1EMN27764 2011/05/11 14-8 A17N8CA.fm Electrical Parts PRODUCT SAFETY NOTE: Products marked with a # have special characteristics important to safety. Before replacing any of these components, read carefully the product safety notice in this service manual. Don't degrade the safety of the product through improper servicing. NOTES: 1. Parts that are not assigned part numbers (---------) are not available. 2. Tolerance of Capacitors and Resistors are noted with the following symbols. C.....±0.25% D.....±0.5% F.....±1% G.....±2% J......±5% K.....±10% M.....±20% N.....±30% Z.....+80/-20% Different parts from the original model 19MF301B/F7 (Serial No. : TH1) Ref. No. Description Part No. DIGITAL ASSEMBLY Consists of the following A17N8MMA-001 DIGITAL MAIN CBA UNIT FUNCTION CBA UNIT IR SENSOR CBA UNIT A17N8MMA-001-DM A17N8MMA-001-FN A17N8MMA-001-IR 2011/05/11 14-9 A17N8EL.fm TYPE B PARTS LIST [LC190SS2 (Serial No.: TH1)] Mechanical Parts PRODUCT SAFETY NOTE: Products marked with a # have special characteristics important to safety. Before replacing any of these components, read carefully the product safety notice in this service manual. Don't degrade the safety of the product through improper servicing. NOTE: Parts that are not assigned part numbers (---------) are not available. Ref. No. Description STAND ASSEMBLY A17N3UT Part No. Ref. No. S3 Description Part No. STYROFOAM BOTTOM A91N8UT 1EM024306 S4 SET BAG A81N0UH 1EM323958A S5 SERIAL NO. LABEL A01PBUH ---------- S6 STAND BAG A81N0UH 1EM425888 ACCESSORIES X1 BAG POLYETHYLENE 235X365XT0.03 0EM408420A X2# OWNERS MANUAL A17N2UT 1EMN27340 X3 REMOTE CONTROL NH210UD NH210UD X4 DRY BATTERY R03/2S XB0M451T0006 X6 QUICK START GUIDE A17N2UT 1EMN27342 X10 REGISTRATION CARD (SYLVANIA) A17N2UT 1EMN27762 1ESA26466 A1 FRONT CABINET A91N3UH 1EM023685 A3 CONTROL PLATE A91N3UH 1EM325763 A4 REAR CABINET A01N0UH 1EM124316 A5 DECORATION PLATE A17N2UT 1EM225869 A6# RATING LABEL A17N2UT ---------- A8 JACK LABEL A9DN0UH 1EM430877 A9 JACK HOLDER(A) A17N3UT 1EM225263 A10 JACK HOLDER(D) A94N0UH 1EM222784 A24 ENERGY STAR LABEL A91F2UH ---------- A42 ENERGY GUIDE LABEL ---------- B1 SHIELD BOX A17N3UT 1EM225363 B2 STAND HOLDER A94N0UH 1EM325619 B3 WALL MOUNT BRACKET A84N0UH 1EM323797 B4 PCB STUD A91N0UH 1EM326198 B7 GASKET A8AF0UH 1EM425861 B8 SPEAKER HOLDER A94N0UH 1EM325677 B44 THERMAL SHEET TMS-14-20 12X12 XK10000X4011 CL201 WIRE ASSEMBLY 11PIN FFC 11PIN 75MM WX1A94N0-105 CL701 WIRE ASSEMBLY 29PIN FFC 29PIN 50MM WX1A94F0-101 CL861 WIRE ASSEMBLY 2PIN 2PIN/75MM/AWG 26 WX1A01N0-002 CL862 WIRE ASSEMBLY 2PIN 2PIN/75MM/AWG 26 WX1A01N0-002 CL3701 WIRE ASSEMBLY 29PIN FFC 29PIN 50MM WX1A94F0-101 CL3702 WIRE ASSEMBLY 29PIN FFC 29PIN 70MM WX1A94F0-111 CL3902 WIRE ASSEMBLY 24PIN FFC 24PIN 65MM WX1A94N0-106 L1 SCREW P-TIGHT 3X10 BIND HEAD+ GBHP3100 L2 SCREW P-TIGHT M3X8 BIND HEAD+ GBJP3080 L3 SCREW S-TIGHT M3X6 BIND HEAD+ GBJS3060 L4 SCREW S-TIGHT M3X8 BIND HEAD+ GBHS3080 L5 SCREW TAP TIGHT M3X10 BIND HEAD+BLK NI GBHS3100 L8 ASSEMBLED SCREW M3X10 1EM420633A L9 DOUBLE SEMS SCREW M4X10 + BLK FPH34100 L11 HEX SCREW #4-40 7MM 1EM430139 L12 ASSEMBLED SCREW ( D9 M3X6 ) A71F0UH 1EM424392B L17 STAND SCREW KIT A01N6UT 1ESA24406 LCD1 LCD MODULE 18.5INCH WIDE CMO 18.5INCH UJ19MXA WXGA SP861 SPEAKER S0307F03 SP862 SPEAKER S0307F03 DS08070XQ001 DS08070XQ001 PACKING S1 CARTON A17N2UT 1EM434118 S2 STYROFOAM TOP A91N8UT 1EM024305 2011/05/11 14-10 A17N2CA.fm Electrical Parts PRODUCT SAFETY NOTE: Products marked with a # have special characteristics important to safety. Before replacing any of these components, read carefully the product safety notice in this service manual. Don't degrade the safety of the product through improper servicing. Ref. No. C631 NOTES: 1. Parts that are not assigned part numbers (---------) are not available. 2. Tolerance of Capacitors and Resistors are noted with the following symbols. C.....±0.25% D.....±0.5% F.....±1% G.....±2% J......±5% K.....±10% M.....±20% N.....±30% Z.....+80/-20% DIGITAL MAIN CBA UNIT Ref. No. Description DIGITAL MAIN CBA UNIT Part No. A17N2MMA-001 MAIN CBA Ref. No. Description MAIN CBA Consists of the following: Part No. A17N3MP1-001 CAPACITORS Description ELECTROLYTIC CAP. 470µF/25V M Part No. CE1EMASDL471 C632 ELECTROLYTIC CAP. 1000µF/35V M CE1GMZPDL102 C633 CERAMIC CAP. B K 1500pF/1KV CCD3AKN0B152 C636# ELECTROLYTIC CAP. 100µF/25V M CE1EMASDL101 C638 ELECTROLYTIC CAP. 2200µF/6.3V M CE0KMZPDL222 C639 ELECTROLYTIC CAP. 2200µF/6.3V M CE0KMZPDL222 C641 ELECTROLYTIC CAP. 3300µF/10V M CE1AMZPDL332 C643 ELECTROLYTIC CAP. 1000µF/25V M CE1EMZPDL102 C645 CAP POLYESTER FILM 0.0022µF/100V J CA2A222SER02 C646 CHIP CERAMIC CAP.(1608) F Z 0.1µF/50V CHD1JZ30F104 C647 ELECTROLYTIC CAP. 100µF/10V M H7 CE1AMAVSL101 C648 ELECTROLYTIC CAP. 47µF/25V M H7 CE1EMAVSL470 C649 ELECTROLYTIC CAP. 220µF/10V M H7 CE1AMAVSL221 C650 ELECTROLYTIC CAP. 220µF/10V M H7 CE1AMAVSL221 C652 ELECTROLYTIC CAP. 1000µF/6.3V M CE0KMASDL102 C653 ELECTROLYTIC CAP. 22µF/50V M CE1JMASDL220 C654 ELECTROLYTIC CAP. 100µF/16V M CE1CMASDL101 CE1JMAVSL220 C655 ELECTROLYTIC CAP. 22µF/50V M H7 C656 CHIP CERAMIC CAP.(1608) F Z 0.1µF/50V CHD1JZ30F104 C661 ELECTROLYTIC CAP. 3.3µF/50V M CE1JMASDL3R3 C681 CHIP CERAMIC CAP.(1608) F Z 0.1µF/50V CHD1JZ30F104 C682 CHIP CERAMIC CAP.(1608) F Z 0.1µF/50V CHD1JZ30F104 C683 CHIP CERAMIC CAP.(1608) F Z 0.1µF/50V CHD1JZ30F104 C684 CHIP CERAMIC CAP.(1608) F Z 0.1µF/50V CHD1JZ30F104 C685 CHIP CERAMIC CAP.(1608) F Z 0.1µF/50V CHD1JZ30F104 C691# CAP CERAMIC 4700pF/250V/M/KX CA2E472MR101 C692# SAFTY CAP. 2200pF/250V KX CA2E222MR101 C802 CHIP CERAMIC CAP.(1608) F Z 0.1µF/50V CHD1JZ30F104 C805 ELECTROLYTIC CAP. 330µF/25V M CE1EMASDL331 C201 ELECTROLYTIC CAP. 470µF/25V M CE1EMASDL471 C806 ELECTROLYTIC CAP. 330µF/25V M CE1EMASDL331 C202 CHIP CERAMIC CAP.(1608) B K 0.01µF/50V CHD1JK30B103 C807 CHIP CERAMIC CAP.(1608) B K 0.022µF/25V CHD1EK30B223 C203 CHIP CERAMIC CAP.(1608) F Z 0.1µF/50V CHD1JZ30F104 C808 CHIP CERAMIC CAP.(1608) B K 0.022µF/25V CHD1EK30B223 C204 ELECTROLYTIC CAP. 10µF/50V M CE1JMASDL100 C809 CHIP CERAMIC CAP. (1608) B K 1µF/16V CHD1CK30B105 CHD1CK30B105 C207 ELECTROLYTIC CAP. 10µF/50V M CE1JMASDL100 C810 CHIP CERAMIC CAP. (1608) B K 1µF/16V C209 ELECTROLYTIC CAP. 47µF/25V M CE1EMASDL470 C811 CHIP CERAMIC CAP.(1608) F Z 0.1µF/50V CHD1JZ30F104 C214 CHIP CERAMIC CAP.(1608) CH J 1000pF/50V CHD1JJ3CH102 C812 ELECTROLYTIC CAP. 470µF/25V M CE1EMASDL471 C215 CHIP CERAMIC CAP.(1608) F Z 0.1µF/50V CHD1JZ30F104 C813 ELECTROLYTIC CAP. 100µF/25V M CE1EMASDL101 C216 CHIP CERAMIC CAP. (1608) B K 1µF/16V CHD1CK30B105 C816 CHIP CERAMIC CAP. CH J 820pF/50V CHD1JJ3CH821 CHD1JJ3CH821 C217 ELECTROLYTIC CAP. 47µF/25V M CE1EMASDL470 C817 CHIP CERAMIC CAP. CH J 820pF/50V C218 CHIP CERAMIC CAP.(1608) F Z 0.1µF/50V CHD1JZ30F104 C825 CHIP CERAMIC CAP. (1608) B K 1µF/16V CHD1CK30B105 C219 CHIP CERAMIC CAP.(1608) F Z 0.1µF/50V CHD1JZ30F104 C826 CHIP CERAMIC CAP.(1608) CH J 390pF/50V CHD1JJ3CH391 C220 CHIP CERAMIC CAP.(1608) F Z 0.1µF/50V CHD1JZ30F104 C827 CHIP CERAMIC CAP. (1608) B K 1µF/16V CHD1CK30B105 C221 CHIP CERAMIC CAP.(1608) F Z 0.1µF/50V CHD1JZ30F104 C828 CHIP CERAMIC CAP.(1608) CH J 390pF/50V CHD1JJ3CH391 C301 CHIP CERAMIC CAP.(1608) F Z 0.1µF/50V CHD1JZ30F104 C829 CHIP CERAMIC CAP.(1608) CH J 1000pF/50V CHD1JJ3CH102 C302 CHIP CERAMIC CAP.(1608) F Z 0.1µF/50V CHD1JZ30F104 C830 CHIP CERAMIC CAP.(1608) CH J 1000pF/50V CHD1JJ3CH102 C303 ELECTROLYTIC CAP. 330µF/10V M CE1AMASDL331 C831 ELECTROLYTIC CAP. 100µF/16V M CE1CMASDL101 C304 CHIP CERAMIC CAP.(1608) F Z 0.1µF/50V CHD1JZ30F104 C832 CHIP CERAMIC CAP.(1608) F Z 0.1µF/50V CHD1JZ30F104 C305 CHIP CERAMIC CAP.(1608) F Z 0.1µF/50V CHD1JZ30F104 C833 CHIP CERAMIC CAP.(1608) F Z 0.1µF/50V CHD1JZ30F104 C306 ELECTROLYTIC CAP. 22µF/50V M CE1JMASDL220 C1001 CAP CERAMIC (AX) 2200pF/50V/B/K CA1J222TU061 C309 CHIP CERAMIC CAP.(1608) CH J 1000pF/50V CHD1JJ3CH102 C1002 CAP POLYESTER FILM 0.022µF/100V J CA2A223SER02 C310 CHIP CERAMIC CAP.(1608) CH J 47pF/50V CHD1JJ3CH470 C1003 CHIP CERAMIC CAP.(1608) B K 0.01µF/50V CHD1JK30B103 C311 CHIP CERAMIC CAP.(1608) CH J 47pF/50V CHD1JJ3CH470 C1004 CHIP CERAMIC CAP.(1608) B K 0.01µF/50V CHD1JK30B103 C401 ELECTROLYTIC CAP. 1µF/50V M CE1JMASDL1R0 C1005 CAP POLYESTER FILM 0.022µF/100V J CA2A223SER02 C601# CAP METALIZED FILM 0.47µF/300V K 3.5MM CT2F474DC004 C1006 CAP CERAMIC HV 10pF/6.3KV/SL/J CCA1000MR001 C603 CAP ELECTROLYTIC 270µF/200V CEA271DYG005 C1007 CAP CERAMIC (AX) 2200pF/50V/B/K CA1J222TU061 C604 CAP POLYESTER FILM 0.039µF/100V J CA2A393SER02 C1008 CAP CERAMIC HV 10pF/6.3KV/SL/J CCA1000MR001 C605 CAP POLYESTER FILM 0.0012µF/100V J CA2A122SER02 C1009 ELECTROLYTIC CAP. 10µF/50V M CE1JMASDL100 C606 CERAMIC CAP. 560pF/2KV CA3D561PAN04 C1010 ELECTROLYTIC CAP. 10µF/50V M CE1JMASDL100 C607 CAP POLYESTER FILM 0.082µF/100V J CA2A823SER02 C1011 ELECTROLYTIC CAP. 1000µF/35V M CE1GMZPDL102 C608 CAP POLYESTER FILM 0.0018µF/100V J CA2A182SER02 2011/05/11 14-11 A17N2EL.fm Ref. No. Description Part No. Ref. No. Description Part No. C1012 CERAMIC CAP. B K 220pF/500V CCD2JKS0B221 D411 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 C1014 CAP CERAMIC HV 10pF/6.3KV/SL/J CCA1000MR001 D412 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 C1015 CAP CERAMIC HV 10pF/6.3KV/SL/J CCA1000MR001 D413 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 C1016 CHIP CERAMIC CAP.(1608) B K 6800pF/50V CHD1JK30B682 D414 DIODE ZENER 6V2BSB-T26 NDTB6R2BST26 C1018 CHIP CERAMIC CAP.(1608) B K 0.1µF/50V CHD1JK30B104 D416 DIODE ZENER 10BSB-T26 NDTB010BST26 C1019 CERAMIC CAP. B K 220pF/500V CCD2JKS0B221 D417 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 C1020 CHIP CERAMIC CAP.(1608) B K 0.1µF/50V CHD1JK30B104 D601# DIODE 1N5397BD NDL1001N5397 C1023 ELECTROLYTIC CAP. 10µF/50V M CE1JMASDL100 D602# DIODE 1N5397BD NDL1001N5397 C1024 CHIP CERAMIC CAP.(1608) B K 0.01µF/50V CHD1JK30B103 D603# DIODE 1N5397BD NDL1001N5397 C1025 CHIP CERAMIC CAP.(1608) B K 0.01µF/50V CHD1JK30B103 D604# DIODE 1N5397BD NDL1001N5397 C1026 CHIP CERAMIC CAP.(1608) B K 0.1µF/50V CHD1JK30B104 D605 DIODE ZENER 4V3BSB-T26 NDTB4R3BST26 NDTB027BST26 C1027 ELECTROLYTIC CAP. 10µF/50V M CE1JMASDL100 D606# DIODE ZENER 27BSB-T26 C1028 CHIP CERAMIC CAP.(1608) B K 0.01µF/50V CHD1JK30B103 D607# DIODE ZENER 39BSB-T26 NDTB039BST26 C1031 CAP POLYESTER FILM 0.0027µF/100V J CA2A272SER02 D608# SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 C1032 CHIP CERAMIC CAP.(1608) B K 0.01µF/50V CHD1JK30B103 D610 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 C1033 ELECTROLYTIC CAP. 10µF/50V M CE1JMASDL100 D612 DIODE ZENER 1ZB220-YBB NDWZ01ZB220Y C1034 CHIP CERAMIC CAP.(1608) B K 0.01µF/50V CHD1JK30B103 D631 DIODE SCHOTTKY SB2A0BD NDWZ000SB2A0 C1035 CHIP CERAMIC CAP.(1608) B K 0.01µF/50V CHD1JK30B103 D632 DIODE SHOTTKY SB3200BR NDWZ3200D027 C1037 CHIP CERAMIC CAP. (1608) B K 1µF/16V CHD1CK30B105 D633# DIODE ZENER 1ZB43BB NDWZ0001ZB43 C1038 CHIP CERAMIC CAP.(1608) B K 0.1µF/50V CHD1JK30B104 D636 DIODE FR104-B NDLZ000FR104 C1039 CHIP CERAMIC CAP.(1608) B K 0.01µF/50V CHD1JK30B103 D637# DIODE ZENER 36BSB-T26 NDTB036BST26 C1040 CHIP CERAMIC CAP.(1608) B K 1000pF/50V CHD1JK30B102 D638 SCHOTTKY BARRIER DIODE SB240-B/P NDWZ000SB240 C1041 CHIP CERAMIC CAP.(1608) B K 0.01µF/50V CHD1JK30B103 D639 DIODE FAST RECOVERY FR151-B/P NDWZ0FR151BP C1042 CHIP CERAMIC CAP.(1608) F Z 0.22µF/50V CHD1JZ30F224 D641 DIODE SCHOTTKY SB360BH NDWZ000SB360 C1043 CHIP CERAMIC CAP.(1608) B K 0.22µF/16V CHD1CK30B224 D642 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 C1044 CHIP CERAMIC CAP.(1608) B K 0.1µF/50V CHD1JK30B104 D643 FAST RECOVERY DIODE FR252 NDWZ000FR252 QDTZ001SS133 C1045 CHIP CERAMIC CAP.(1608) B K 0.1µF/50V CHD1JK30B104 D645 SWITCHING DIODE 1SS133(T-77) C1052 CHIP CERAMIC CAP.(1608) B K 0.1µF/50V CHD1JK30B104 D646 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 C1053 ELECTROLYTIC CAP. 100µF/25V M CE1EMASDL101 D648 DIODE ZENER HZS5.6NB2TE-EQ QDTB0HZS5R6N C1054 CHIP CERAMIC CAP.(1608) B K 0.1µF/50V CHD1JK30B104 D649# DIODE ZENER 3V3BSB-T26 NDTB3R3BST26 C1056 CHIP CERAMIC CAP.(1608) B K 0.1µF/50V CHD1JK30B104 D650 DIODE ZENER 6V8BSA-T26 NDTA6R8BST26 D651 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 D653 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 D654 DIODE FR154 NDLZ000FR154 CONNECTORS CN102 PH CONNECTOR TOP 8P B8B-PH-K-S (LF)(SN) J3PHC08JG029 CN201 FFC CONNECTOR IMSA-9615S-11A-PP-A JC96J11ER007 D655 DIODE FR154 NDLZ000FR154 CN301 FFC CONNECTOR IMSA-9615S-29A-PP-A JC96J29ER007 D656 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 CN302 FFC CONNECTOR IMSA-9615S-29A-PP-A JC96J29ER007 D657 DIODE ZENER 4V7BSB-T26 NDTB4R7BST26 CN702 FFC CONNECTOR IMSA-9615S-29A-PP-A JC96J29ER007 D659 SHUNT REGULATOR KIA431B-AT/P NSZBA0TJY038 CN872 PH CONNECTOR TOP 2P B2B-PH-K-S (LF)(SN) J3PHC02JG029 D660 WIRE CP STP-S-0.50 XZ40F0REN001 D662 IC SHUNT REGULATOR KIA431-AT/P NSZBA0TJY036 D665 WIRE CP STP-S-0.50 XZ40F0REN001 D666 DIODE ZENER 10BSB-T26 NDTB010BST26 D668# DIODE ZENER 27BSB-T26 NDTB027BST26 D670 SCHOTTKY BARRIER DIODE SB160 NDWZ000SB160 D804 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 D805 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 D808 DIODE ZENER 20BSB-T26 NDTB020BST26 D809 DIODE ZENER 20BSB-T26 NDTB020BST26 D1001 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 D1002 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 D1003 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 D1004 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 D1005 DIODE ZENER 6V2BSB-T26 NDTB6R2BST26 D1006 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 D1007 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 D1008 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 D1009 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 D1010 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 D1011 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 D1012 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 D1013 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 D1014 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 D1015 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 CN1001# CONNECTOR PRINT OSU KW05-120-02-00 J30502KET001 CN1002# CONNECTOR PRINT OSU KW05-120-02-00 J30502KET001 DIODES D201 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 D202 IC SHUNT REGULATOR KIA431-AT/P NSZBA0TJY036 D203 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 D204 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 D205 DIODE ZENER 24BSC-T26 NDTC024BST26 D206 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 D207 DIODE ZENER 7V5BSA-T26 NDTA7R5BST26 D208 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 D209 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 D210 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 D303 DIODE ZENER 5V6BSB-T26 NDTB5R6BST26 D401 DIODE FR104-B NDLZ000FR104 D402 DIODE ZENER 10BSB-T26 NDTB010BST26 D404 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 D405 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 D406 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 D407 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 D408 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 D409 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 D410 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 2011/05/11 14-12 A17N2EL.fm Ref. No. Description Part No. Ref. No. Description TRANSISTOR KTC3199-GR-AT/P Part No. D1016 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 Q1003 NQS4KTC3199P D1018 DIODE ZENER 10BSB-T26 NDTB010BST26 Q1004 TRANSISTOR KTC3199-GR-AT/P NQS4KTC3199P D1020 DIODE ZENER 5V1BSB-T26 NDTB5R1BST26 Q1005# FET MOS SMD TPC8214-H QF2ZTPC8214H NQS1KTA1267P D1021 DIODE ZENER 15BSB-T26 NDTB015BST26 Q1006 TRANSISTOR KTA1267-GR-AT/P D1022 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 Q1007 TRANSISTOR KTA1267-GR-AT/P NQS1KTA1267P D1023 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 Q1008 TRANSISTOR KTC3199-GR-AT/P NQS4KTC3199P D1024 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 Q1009 TRANSISTOR KTC3199-GR-AT/P NQS4KTC3199P D1025 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 Q1010 TRANSISTOR KTC3199-GR-AT/P NQS4KTC3199P D1026 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 Q1011 TRANSISTOR 2SA950-Y(TE2 F T) QQSY02SA950F D1027 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 Q1012 TRANSISTOR KTC3199-GR-AT/P NQS4KTC3199P D1028# DIODE ZENER 4V7BSB-T26 NDTB4R7BST26 Q1014 TRANSISTOR KTC3199-GR-AT/P NQS4KTC3199P D1029 DIODE ZENER 16BSB-T26 NDTB016BST26 Q1015 TRANSISTOR KTC3199-GR-AT/P NQS4KTC3199P D1030 DIODE ZENER 16BSB-T26 NDTB016BST26 Q1016 TRANSISTOR KTC3199-GR-AT/P NQS4KTC3199P D1034 DIODE ZENER 9V1BSB-T26 NDTB9R1BST26 Q1017 TRANSISTOR KTC3199-GR-AT/P NQS4KTC3199P D1036 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 Q1018 TRANSISTOR KTA1267-GR-AT/P NQS1KTA1267P D1037 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 Q1019 TRANSISTOR KTC3199-GR-AT/P NQS4KTC3199P D1038 WIRE CP STP-S-0.50 XZ40F0REN001 Q1023 TRANSISTOR KTC3199-GR-AT/P NQS4KTC3199P D1045 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 Q1024 TRANSISTOR KTA1267-GR-AT/P NQS1KTA1267P ICS RESISTORS IC201 IC TL3472CDR NSZBA0TTY115 R172 RES CARBON FILM T 1/4W J 22k Ω RCX4223T1001 IC601# PHOTO COUPLER LTV817MCF NPECLTV817MF R175 CHIP RES. 1/10W J 22k Ω RRXAJR5Z0223 IC631 IC LD1117V NSZBA0SSS046 R176 CHIP RES.(1608) 1/10W 0 Ω RRXAZR5Z0000 IC801 AUDIO AMP IC TDA1517P/N3 112 NSCA0SNXP003 R201 METAL OXIDE FILM RES. 1W J 5.6 Ω RN015R6ZU001 IC803 IC OP AMP NJM4558M(TE1)-#ZZZB QSZBA0TJR089 R202 CHIP RES. 1/10W F 9.1k Ω RRXAFR5H9101 IC1001 IC PULSE-WIDTH-MODULATION CONT TL494CDR NSCA0T0TY006 R203 CHIP RES. 1/10W F 510 Ω RRXAFR5H5100 R204 RRXAFR5H2201 IC OPERATIONNAL AMPLIFIER KIA358F-EL NSZBA0TJY030 CHIP RES. 1/10W F 2.2k Ω R205 CHIP RES. 1/10W J 1.5k Ω RRXAJR5Z0152 R206 CHIP RES. 1/10W J 47k Ω RRXAJR5Z0473 IC1002 COILS L301 BEADS INDUCTOR FBR07HA121SB-00 LLBF00STU030 R207 RES CARBON FILM T 1/4W J 6.8k Ω RCX4682T1001 L302 CHIP INDUCTOR LK1608R22K-T LLACKB3TUR22 R208 RES CARBON FILM T 1/4W J 6.8k Ω RCX4682T1001 L303 CHIP INDUCTOR LK1608R22K-T LLACKB3TUR22 R209 CHIP RES. 1/10W J 56k Ω RRXAJR5Z0563 L601# LINE FILTER 5.0MH 96005 LLBG00ZKT004 R210 CHIP RES. 1/10W J 6.8k Ω RRXAJR5Z0682 R211 CHIP RES. 1/10W J 10k Ω RRXAJR5Z0103 TRANSISTORS Q171 TRANSISTOR KTC3199-GR-AT/P NQS4KTC3199P R212 CHIP RES. 1/10W J 22k Ω RRXAJR5Z0223 Q172 TRANSISTOR KTC3199-GR-AT/P NQS4KTC3199P R213 CHIP RES. 1/10W J 27k Ω RRXAJR5Z0273 Q201 TRANSISTOR 2SD400(F) QQUF002SD400 R214 CHIP RES. 1/10W J 3.3k Ω RRXAJR5Z0332 Q202 TRANSISTOR KTA1267-GR-AT/P NQS1KTA1267P R215 RES CARBON FILM T 1/4W J 330 Ω RCX4331T1001 Q203 TRANSISTOR KTC3199-GR-AT/P NQS4KTC3199P R216 RES CARBON FILM T 1/4W J 2.7k Ω RCX4272T1001 Q205 TRANSISTOR KTC3199-GR-AT/P NQS4KTC3199P R217 RES CARBON FILM T 1/4W J 2.7k Ω RCX4272T1001 Q206 TRANSISTOR KTC3199-GR-AT/P NQS4KTC3199P R218 RES CARBON FILM T 1/4W J 8.2k Ω RCX4822T1001 Q207 TRANSISTOR 2SC2655-Y(TE6 F M) QQSY2SC2655F R219 RES CARBON FILM T 1/4W J 10 Ω RCX4100T1001 Q208 TRANSISTOR 2SA1020-Y(TE6 F M) QQSY2SA1020F R220 CHIP RES. 1/10W J 47k Ω RRXAJR5Z0473 Q209 TRANSISTOR KTC3199-GR-AT/P NQS4KTC3199P R221 CHIP RES. 1/10W J 22k Ω RRXAJR5Z0223 Q210 TRANSISTOR KTC3199-GR-AT/P NQS4KTC3199P R222 RES CARBON FILM T 1/4W J 120 Ω RCX4121T1001 Q401 TRANSISTOR KTC3199-GR-AT/P NQS4KTC3199P R223 RES CARBON FILM T 1/4W J 15k Ω RCX4153T1001 Q402 TRANSISTOR KTC3199-GR-AT/P NQS4KTC3199P R224 CHIP RES. 1/10W J 1 Ω RRXAJR5Z01R0 Q601# FET MOS TK5A50D(FUNAI QEWZTK5A50DQ R225 CHIP RES.(1608) 1/10W 0 Ω RRXAZR5Z0000 Q602# TRANSISTOR 2SC2120-Y(TE2 F T) QQSY2SC2120F R226 RES CARBON FILM T 1/4W J 10 Ω RCX4100T1001 Q631 TRANSISTOR KTC3199-GR-AT/P NQS4KTC3199P R227 CHIP RES. 1/10W J 100k Ω RRXAJR5Z0104 Q633 TRANSISTOR KTC3199-GR-AT/P NQS4KTC3199P R228 WIRE CP STP-S-0.50 XZ40F0REN001 Q634 TRANSISTOR KTC3199-GR-AT/P NQS4KTC3199P R229 RES CARBON FILM T 1/4W J 10 Ω RCX4100T1001 Q635 TRANSISTOR 2SC2120-Y(TE2 F T) QQSY2SC2120F R230 CHIP RES. 1/10W J 10k Ω RRXAJR5Z0103 Q636 TRANSISTOR 2SC2120-Y(TE2 F T) QQSY2SC2120F R231 CHIP RES. 1/10W J 1.5k Ω RRXAJR5Z0152 Q637 TRANSISTOR 2SC2120-Y(TE2 F T) QQSY2SC2120F R232 CHIP RES. 1/10W J 15k Ω RRXAJR5Z0153 Q638 TRANSISTOR KTC3199-GR-AT/P NQS4KTC3199P R233 CHIP RES. 1/10W J 10k Ω RRXAJR5Z0103 Q639 TRANSISTOR KTA1267-GR-AT/P NQS1KTA1267P R234 CHIP RES. 1/10W J 1k Ω RRXAJR5Z0102 Q640 NPN TRANSISTOR POWER 2SC4881F HFE MAX320 QQWZ2SC4881F R238 CHIP RES.(1608) 1/10W 0 Ω RRXAZR5Z0000 Q641 TRANSISTOR KTC3199-GR-AT/P NQS4KTC3199P R239 RES CARBON FILM T 1/4W J 150 Ω RCX4151T1001 Q643 TRANSISTOR 2SA950-Y(TE2 F T) QQSY02SA950F R240 RES CARBON FILM T 1/4W J 3.9k Ω RCX4392T1001 Q801 TRANSISTOR KTC3199-GR-AT/P NQS4KTC3199P R302 CHIP RES.(1608) 1/10W 0 Ω RRXAZR5Z0000 Q1001 TRANSISTOR KTC3199-GR-AT/P NQS4KTC3199P R303 CHIP RES.(1608) 1/10W 0 Ω RRXAZR5Z0000 Q1002 TRANSISTOR KTC3199-GR-AT/P NQS4KTC3199P R304 CHIP RES. 1/10W J 56 Ω RRXAJR5Z0560 2011/05/11 14-13 A17N2EL.fm Ref. No. Description Part No. Ref. No. Description METAL OXIDE RES. 1W J 0.18 Ω Part No. R305 CHIP RES. 1/10W J 56 Ω RRXAJR5Z0560 R672 R313 CHIP RES.(1608) 1/10W 0 Ω RRXAZR5Z0000 R673 CHIP RES. 1/10W F 3.6k Ω RRXAFR5H3601 R401# CHIP RES. 1/10W J 1 Ω RRXAJR5Z01R0 R674 CHIP RES. 1/10W F 10k Ω RRXAFR5H1002 RN01R18ZU001 R402 CHIP RES. 1/10W F 5.6k Ω RRXAFR5H5601 R675 RES CARBON FILM T 1/4W J 1.0k Ω RCX4102T1001 R403 CHIP RES. 1/10W F 36k Ω RRXAFR5H3602 R676 RES CARBON FILM T 1/4W J 22 Ω RCX4220T1001 R406 RES CARBON FILM T 1/4W J 47k Ω RCX4473T1001 R677 CHIP RES. 1/10W J 1k Ω RRXAJR5Z0102 R407 CHIP RES. 1/10W J 47k Ω RRXAJR5Z0473 R679 RES CARBON FILM T 1/4W J 10k Ω RCX4103T1001 R408 CHIP RES. 1/10W J 47k Ω RRXAJR5Z0473 R681 CHIP RES. 1/10W F 820 Ω RRXAFR5H8200 R409 CHIP RES. 1/10W J 2.2k Ω RRXAJR5Z0222 R682 WIRE CP STP-S-0.50 XZ40F0REN001 R411 RES CARBON FILM T 1/4W J 22k Ω RCX4223T1001 R683 METAL OXIDE FILM RES. 1W J 3.3 Ω RN013R3ZU001 R412 CHIP RES. 1/10W J 22k Ω RRXAJR5Z0223 R684 METAL OXIDE FILM RES. 1W J 3.3 Ω RN013R3ZU001 R413 CHIP RES. 1/10W J 22k Ω RRXAJR5Z0223 R685 CHIP RES. 1/10W F 620 Ω RRXAFR5H6200 R601# GLASS GLAZE RES. 1/2W J 1M Ω RXX2JZLZ0105 R686 CHIP RES. 1/10W F 1.0k Ω RRXAFR5H1001 R602 CEMENT RES. 3W K 1.2 Ω RW031R2PG007 R688 RES CARBON FILM T 1/4W J 1.0 Ω RCX41R0T1001 R603 RES CARBON FILM 1/4W J 390k Ω RCX4394FS002 R689 RES CARBON FILM T 1/4W J 33 Ω RCX4330T1001 R604 RES CARBON FILM 1/4W J 390k Ω RCX4394FS002 R690 RES CARBON FILM T 1/4W J 3.3 Ω RCX43R3T1001 R605 RES CARBON FILM 1/4W J 390k Ω RCX4394FS002 R699 RES CARBON FILM T 1/4W J 56 Ω RCX4560T1001 R606 RES CARBON FILM 1/4W J 330k Ω RCX4334FS002 R803 CHIP RES. 1/10W J 10k Ω RRXAJR5Z0103 R607 RES CARBON FILM T 1/4W J 150 Ω RCX4151T1001 R804 CHIP RES. 1/10W J 8.2 Ω RRXAJR5Z08R2 R608 RES CARBON FILM T 1/4W J 150 Ω RCX4151T1001 R805 CHIP RES. 1/10W J 8.2 Ω RRXAJR5Z08R2 R609 RES CARBON FILM T 1/4W J 1.5k Ω RCX4152T1001 R806 WIRE CP STP-S-0.50 XZ40F0REN001 R610# METAL OXIDE FILM RES. 2W J 0.39 Ω RN02R39ZU001 R807 WIRE CP STP-S-0.50 XZ40F0REN001 R611 RES CARBON FILM T 1/4W J 2.2k Ω RCX4222T1001 R808 CHIP RES. 1/10W J 4.7k Ω RRXAJR5Z0472 R612 RES CARBON FILM T 1/4W J 220 Ω RCX4221T1001 R809 CHIP RES. 1/10W J 360 Ω RRXAJR5Z0361 R631 RES CARBON FILM T 1/4W J 12k Ω RCX4123T1001 R810 CHIP RES. 1/10W J 12k Ω RRXAJR5Z0123 R632 RES CHIP 1608 1/10W D 1.10k Ω RTW1101HH007 R811 CHIP RES. 1/10W J 1.2k Ω RRXAJR5Z0122 R633 RES CHIP 1608 1/10W D 10.0k Ω RTW1002HH007 R813 CHIP RES. 1/10W J 1.2k Ω RRXAJR5Z0122 R634 RES CARBON FILM T 1/4W J 12k Ω RCX4123T1001 R814 CHIP RES. 1/10W J 12k Ω RRXAJR5Z0123 R635 RES CARBON FILM T 1/4W J 220 Ω RCX4221T1001 R815 CHIP RES. 1/10W J 470 Ω RRXAJR5Z0471 R637 RES CARBON FILM T 1/4W J 220 Ω RCX4221T1001 R816 CHIP RES. 1/10W J 470 Ω RRXAJR5Z0471 R638 RES CARBON FILM T 1/4W J 2.7k Ω RCX4272T1001 R817 CHIP RES. 1/10W J 18k Ω RRXAJR5Z0183 R639 CHIP RES. 1/10W F 820 Ω RRXAFR5H8200 R818 CHIP RES. 1/10W J 15k Ω RRXAJR5Z0153 R640 CHIP RES. 1/10W F 18k Ω RRXAFR5H1802 R819 CHIP RES. 1/10W J 10k Ω RRXAJR5Z0103 R641 CHIP RES. 1/10W F 120 Ω RRXAFR5H1200 R820 CHIP RES. 1/10W J 4.7k Ω RRXAJR5Z0472 R642 CHIP RES. 1/10W F 22k Ω RRXAFR5H2202 R821 CHIP RES. 1/10W J 100k Ω RRXAJR5Z0104 R643 CHIP RES. 1/10W F 22k Ω RRXAFR5H2202 R823 CHIP RES. 1/10W J 100k Ω RRXAJR5Z0104 R644 CHIP RES. 1/10W F 22k Ω RRXAFR5H2202 R826 RES CARBON FILM T 1/4W J 10k Ω RCX4103T1001 R645 CHIP RES. 1/10W F 7.50 k Ω RRXAFR5H7501 R830 CHIP RES. 1/10W J 10k Ω RRXAJR5Z0103 R646 CHIP RES. 1/10W F 820 Ω RRXAFR5H8200 R834 CHIP RES. 1/10W J 10k Ω RRXAJR5Z0103 R647 CHIP RES. 1/10W J 47k Ω RRXAJR5Z0473 R836 CHIP RES. 1/10W J 100k Ω RRXAJR5Z0104 R648 CHIP RES. 1/10W J 10k Ω RRXAJR5Z0103 R837 CHIP RES. 1/10W J 100k Ω RRXAJR5Z0104 R649# RES CARBON FILM T 1/4W J 680 Ω RCX4681T1001 R838 RES CARBON FILM T 1/4W J 10k Ω RCX4103T1001 R650 RES CARBON FILM T 1/4W J 680 Ω RCX4681T1001 R842 CHIP RES. 1/10W J 100k Ω RRXAJR5Z0104 R651# RES CARBON FILM T 1/4W J 15 Ω RCX4150T1001 R1001 RES CARBON FILM T 1/4W J 2.2k Ω RCX4222T1001 R652 WIRE CP STP-S-0.50 XZ40F0REN001 R1002 RES CARBON FILM T 1/4W J 180 Ω RCX4181T1001 R653 CHIP RES. 1/10W F 820 Ω RRXAFR5H8200 R1003 RES CARBON FILM T 1/4W J 2.2k Ω RCX4222T1001 R654 CHIP RES. 1/10W F 820 Ω RRXAFR5H8200 R1004 CHIP RES. 1/10W J 10k Ω RRXAJR5Z0103 R655 RES CARBON FILM T 1/4W J 470 Ω RCX4471T1001 R1005 CHIP RES. 1/10W J 22k Ω RRXAJR5Z0223 R656 RES CARBON FILM T 1/4W J 680 Ω RCX4681T1001 R1006 RES CARBON FILM T 1/4W J 180 Ω RCX4181T1001 R658 RES CARBON FILM T 1/4W J 2.7k Ω RCX4272T1001 R1007 RES CARBON FILM T 1/4W J 10 Ω RCX4100T1001 R659 RES. CARBON FILM J 1/2W J 2.7 Ω RCX22R7T1003 R1008 RES CARBON FILM T 1/4W J 12k Ω RCX4123T1001 R660 RES CHIP 1608 1/10W D 10.0k Ω RTW1002HH007 R1009 CHIP RES. 1/10W J 1k Ω RRXAJR5Z0102 R661 RES CARBON FILM T 1/4W J 680 Ω RCX4681T1001 R1010 RES CARBON FILM T 1/4W J 10 Ω RCX4100T1001 R662 RES CARBON FILM T 1/4W J 39 Ω RCX4390T1001 R1011 CHIP RES. 1/10W J 12k Ω RRXAJR5Z0123 R663 RES CARBON FILM T 1/4W J 3.3 Ω RCX43R3T1001 R1012 RES CARBON FILM T 1/4W J 27k Ω RCX4273T1001 R664 RES CARBON FILM T 1/4W J 3.9 Ω RCX43R9T1001 R1013 RES CARBON FILM T 1/4W J 12k Ω RCX4123T1001 R665 RES CARBON FILM T 1/4W J 3.9 Ω RCX43R9T1001 R1014 RES CARBON FILM T 1/4W J 27k Ω RCX4273T1001 R666 CHIP RES. 1/10W J 22k Ω RRXAJR5Z0223 R1015 CHIP RES. 1/10W J 10k Ω RRXAJR5Z0103 R667 CHIP RES. 1/10W J 1k Ω RRXAJR5Z0102 R1017 RES CARBON FILM T 1/4W J 12k Ω RCX4123T1001 R668 CHIP RES. 1/10W J 22k Ω RRXAJR5Z0223 R1018 CHIP RES. 1/10W J 390 Ω RRXAJR5Z0391 R669 CHIP RES. 1/10W J 10k Ω RRXAJR5Z0103 R1019 CHIP RES. 1/10W J 390 Ω RRXAJR5Z0391 R670 RES CARBON FILM T 1/4W J 270 Ω RCX4271T1001 R1020 CHIP RES. 1/10W J 1k Ω RRXAJR5Z0102 R671 RES CARBON FILM T 1/4W J 10 Ω RCX4100T1001 R1022 CHIP RES. 1/10W J 33k Ω RRXAJR5Z0333 2011/05/11 14-14 A17N2EL.fm Ref. No. R1023 Description Ref. No. Part No. Description CHIP RES. 1/10W J 10k Ω RRXAJR5Z0103 R1106 CHIP RES. 1/10W J 10k Ω Part No. RRXAJR5Z0103 R1024 CHIP RES. 1/10W F 22k Ω RRXAFR5H2202 R1107 CHIP RES. 1/10W J 10k Ω RRXAJR5Z0103 R1025 CHIP RES. 1/10W J 1.5k Ω RRXAJR5Z0152 R1108 WIRE CP STP-S-0.50 XZ40F0REN001 R1026 RES CARBON FILM T 1/4W J 2.2k Ω RCX4222T1001 R1109 CHIP RES. 1/10W F 2.2k Ω RRXAFR5H2201 R1027 CHIP RES. 1/10W J 5.1k Ω RRXAJR5Z0512 R1110 CHIP RES. 1/10W J 10k Ω RRXAJR5Z0103 R1028 CHIP RES. 1/10W J 1k Ω RRXAJR5Z0102 R1111 RES CARBON FILM T 1/4W J 10k Ω RCX4103T1001 R1029 RES CARBON FILM T 1/4W J 1.8k Ω RCX4182T1001 R1112 CHIP RES.(1608) 1/10W 0 Ω RRXAZR5Z0000 R1030 RES CARBON FILM T 1/4W J 12k Ω RCX4123T1001 R1117 WIRE CP STP-S-0.50 XZ40F0REN001 R1031 RES CARBON FILM T 1/4W J 4.7k Ω RCX4472T1001 R1118 RES CARBON FILM T 1/4W J 1.2 Ω RCX41R2T1001 R1032# METAL OXIDE FILM RES. 2W J 0.33 Ω RN02R33ZU001 MISCELLANEOUS R1035 CHIP RES. 1/10W F 1.0k Ω RRXAFR5H1001 AC601# AC CORD PB8K9F9110A-057 WAC0172LW008 R1036 CHIP RES. 1/10W F 15k Ω RRXAFR5H1502 B13 HEAT SINK PMU A8A70UH 1EM324377 R1037 CHIP RES.(1608) 1/10W 0 Ω RRXAZR5Z0000 B14 POW HEAT SINK A7120UH 1EM423993 R1038 CHIP RES. 1/10W J 240k Ω RRXAJR5Z0244 BC301 CHIP INDUCTOR BK1608HS601-T LLC601NTU017 R1039 CHIP RES. 1/10W F 68k Ω RRXAFR5H6802 BC601 BEADS INDUCTOR FBR07HA121SB-00 LLBF00STU030 R1040 CHIP RES. 1/10W F 6.2k Ω RRXAFR5H6201 BC801 CHIP INDUCTOR BK1608HS601-T LLC601NTU017 R1041 CHIP RES. 1/10W F 1.0k Ω RRXAFR5H1001 F601# FUSE STC4A125V U/CT PAGE20CW3402 R1042 CHIP RES. 1/10W J 22k Ω RRXAJR5Z0223 FH601 FUSE HOLDER MSF-015 LF (B110) XH01Z00LY002 R1043 CHIP RES. 1/10W F 5.1k Ω RRXAFR5H5101 FH602 FUSE HOLDER MSF-015 LF (B110) XH01Z00LY002 R1044 RES CARBON FILM T 1/4W G 5.1k Ω RCX4512T1002 JS304 CHIP RES.(1608) 1/10W 0 Ω RRXAZR5Z0000 R1045 CHIP RES. 1/10W J 240k Ω RRXAJR5Z0244 JS305 WIRE CP STP-S-0.50 XZ40F0REN001 R1046 CHIP RES. 1/10W J 24k Ω RRXAJR5Z0243 JS306 WIRE CP STP-S-0.50 XZ40F0REN001 R1048 CHIP RES. 1/10W J 22k Ω RRXAJR5Z0223 JS801 CHIP RES.(1608) 1/10W 0 Ω RRXAZR5Z0000 R1049 RES CARBON FILM T 1/4W J 12k Ω RCX4123T1001 JS802 CHIP RES.(1608) 1/10W 0 Ω RRXAZR5Z0000 R1050 CHIP RES. 1/10W J 390k Ω RRXAJR5Z0394 JS803 CHIP RES.(1608) 1/10W 0 Ω RRXAZR5Z0000 R1051 CHIP RES. 1/10W J 390k Ω RRXAJR5Z0394 JS804 CHIP RES.(1608) 1/10W 0 Ω RRXAZR5Z0000 R1052 CHIP RES. 1/10W F 100k Ω RRXAFR5H1003 JS1005 WIRE CP STP-S-0.50 XZ40F0REN001 R1054 CHIP RES. 1/10W F 5.6k Ω RRXAFR5H5601 JS1007 WIRE CP STP-S-0.50 XZ40F0REN001 R1055 CHIP RES. 1/10W F 51.0 k Ω RRXAFR5H5102 JS1011 WIRE CP STP-S-0.50 XZ40F0REN001 R1056 CHIP RES. 1/10W F 100k Ω RRXAFR5H1003 JS1012 WIRE CP STP-S-0.50 XZ40F0REN001 R1058 CHIP RES. 1/10W F 10k Ω RRXAFR5H1002 L13 SCREW B-TIGHT D3X8 BIND HEAD+ GBJB3080 R1059 CHIP RES. 1/10W F 10k Ω RRXAFR5H1002 SA601# SURGE ABSORBER 470V+-10PER NVQZ10D471KB R1060 CHIP RES. 1/10W J 10k Ω RRXAJR5Z0103 T601# TRANS POWER BCK-28-9923 LTT2PC0XB044 R1061 CHIP RES. 1/10W J 33k Ω RRXAJR5Z0333 TM601 EYELET TYPE D-1 0VM406868 0VM406868 R1062 CHIP RES. 1/10W J 390k Ω RRXAJR5Z0394 TM602 EYELET TYPE D-1 R1064 CHIP RES. 1/10W J 33k Ω RRXAJR5Z0333 T1002# TRANS INVERTER HVT-160 LTZ3PZ0XB014 R1065 RES CARBON FILM T 1/4W J 2.7k Ω RCX4272T1001 TU302 TUNER UNIT ATSC TDAU4-D05A UTNATS0AL002 R1066 RES CARBON FILM T 1/4W J 2.7k Ω RCX4272T1001 R1067 CHIP RES. 1/10W J 1k Ω RRXAJR5Z0102 R1068 CHIP RES. 1/10W J 1k Ω RRXAJR5Z0102 R1069 CHIP RES. 1/10W J 1k Ω RRXAJR5Z0102 R1070 CHIP RES. 1/10W J 1k Ω RRXAJR5Z0102 R1071 CHIP RES. 1/10W F 4.3k Ω RRXAFR5H4301 R1072 CHIP RES.(1608) 1/10W 0 Ω RRXAZR5Z0000 R1073 CHIP RES. 1/10W F 1.2k Ω RRXAFR5H1201 R1074 RES CARBON FILM T 1/4W J 100k Ω RCX4104T1001 R1081 CHIP RES. 1/10W F 100k Ω RRXAFR5H1003 R1082 CHIP RES. 1/10W F 68k Ω RRXAFR5H6802 R1083 CHIP RES. 1/10W F 1M Ω RRXAFR5H1004 JACK ASSEMBLY Ref. No. Description Part No. JACK ASSEMBLY Consists of the following A17N3MJC-001 JACK CBA(MJC-A) FUNCTION CBA(MJC-B) A17N3MJC-001-JK A17N3MJC-001-FN JACK CBA Ref. No. Description JACK CBA(MJC-A) Consists of the following Part No. ---------- R1084 CHIP RES. 1/10W J 100k Ω RRXAJR5Z0104 R1086 CHIP RES. 1/10W F 100k Ω RRXAFR5H1003 R1087 CHIP RES. 1/10W F 68k Ω RRXAFR5H6802 C703 CHIP CERAMIC CAP. (1608) F Z 1µF/16V CHD1CZ30F105 R1088 CHIP RES. 1/10W F 1M Ω RRXAFR5H1004 C704 CHIP CERAMIC CAP. (1608) F Z 1µF/16V CHD1CZ30F105 R1089 CHIP RES. 1/10W F 12k Ω RRXAFR5H1202 C723 CHIP CERAMIC CAP. (1608) F Z 1µF/16V CHD1CZ30F105 R1090 CHIP RES. 1/10W F 47.0 k Ω RRXAFR5H4702 C724 CHIP CERAMIC CAP. (1608) F Z 1µF/16V CHD1CZ30F105 R1091 RES CARBON FILM T 1/4W J 12k Ω RCX4123T1001 C731 CHIP CERAMIC CAP. CH J 39pF/50V CHD1JJ3CH390 CAPACITORS R1092 RES CARBON FILM T 1/4W J 12k Ω RCX4123T1001 C732 CHIP CERAMIC CAP. CH J 39pF/50V CHD1JJ3CH390 R1093 RES CARBON FILM T 1/4W J 12k Ω RCX4123T1001 C733 CHIP CERAMIC CAP. CH J 39pF/50V CHD1JJ3CH390 R1094 RES CARBON FILM T 1/4W J 12k Ω RCX4123T1001 C734 CHIP RES.(1608) 1/10W 0 Ω RRXAZR5Z0000 R1095 RES CARBON FILM T 1/4W J 1.2k Ω RCX4122T1001 C735 CHIP RES.(1608) 1/10W 0 Ω RRXAZR5Z0000 R1099 CHIP RES. 1/10W J 1k Ω RRXAJR5Z0102 C736 CHIP RES.(1608) 1/10W 0 Ω RRXAZR5Z0000 R1100 WIRE CP STP-S-0.50 XZ40F0REN001 C743 CHIP CERAMIC CAP. (1608) F Z 1µF/16V CHD1CZ30F105 R1105 CHIP RES. 1/10W J 3.3k Ω RRXAJR5Z0332 C744 CHIP CERAMIC CAP. (1608) F Z 1µF/16V CHD1CZ30F105 2011/05/11 14-15 A17N2EL.fm Ref. No. Description Ref. No. Part No. Description Part No. RES CARBON FILM T 1/4W J 10 Ω RCX4100T1001 R763 RES CARBON FILM T 1/4W J 56k Ω RCX4563T1001 R764 CHIP RES. 1/10W J 56k Ω RRXAJR5Z0563 CHD1CZ30F105 R772 CHIP RES. 1/10W J 10k Ω RRXAJR5Z0103 ELECTROLYTIC CAP. 100µF/16V M H7 CE1CMAVSL101 R773 CHIP RES. 1/10W J 10k Ω RRXAJR5Z0103 C772 CHIP CERAMIC CAP.(1608) F Z 0.1µF/50V CHD1JZ30F104 R774 RES CARBON FILM T 1/4W J 10k Ω RCX4103T1001 C773 CHIP CERAMIC CAP. (1608) F Z 1µF/16V CHD1CZ30F105 R775 RES CARBON FILM T 1/4W J 10k Ω RCX4103T1001 C775 CHIP CERAMIC CAP.(1608) CH J 33pF/50V CHD1JJ3CH330 R780 CHIP RES. 1/10W J 82k Ω RRXAJR5Z0823 C776 CHIP CERAMIC CAP.(1608) CH J 33pF/50V CHD1JJ3CH330 R781 CHIP RES. 1/10W J 82k Ω RRXAJR5Z0823 C841 CHIP CERAMIC CAP. (1608) F Z 1µF/16V CHD1CZ30F105 R782 RES CARBON FILM T 1/4W J 82k Ω RCX4823T1001 C842 CHIP CERAMIC CAP. (1608) F Z 1µF/16V CHD1CZ30F105 R783 CHIP RES. 1/10W J 82k Ω RRXAJR5Z0823 C843 CHIP CERAMIC CAP.(1608) F Z 0.1µF/50V CHD1JZ30F104 R784 CHIP RES. 1/10W J 100k Ω RRXAJR5Z0104 C845 CHIP CERAMIC CAP.(1608) CH J 33pF/50V CHD1JJ3CH330 C753 CHIP CERAMIC CAP.(1608) CH J 100pF/50V CHD1JJ3CH101 R758 C756 CHIP RES.(1608) 1/10W 0 Ω RRXAZR5Z0000 C757 CHIP CERAMIC CAP. (1608) F Z 1µF/16V CHD1CZ30F105 C758 CHIP CERAMIC CAP. (1608) F Z 1µF/16V C771 CONNECTORS R785 CHIP RES. 1/10W J 100k Ω RRXAJR5Z0104 R786 CHIP RES. 1/10W J 100k Ω RRXAJR5Z0104 CN701 FFC CONNECTOR IMSA-9615S-29A-PP-A JC96J29ER007 R787 CHIP RES. 1/10W J 100k Ω RRXAJR5Z0104 CN871 PH CONNECTOR TOP 2P B2B-PH-K-S (LF)(SN) J3PHC02JG029 R788 RES CARBON FILM T 1/4W J 82k Ω RCX4823T1001 R789 RES CARBON FILM T 1/4W J 82k Ω RCX4823T1001 R790 CHIP RES. 1/10W J 82k Ω RRXAJR5Z0823 DIODES D701 ZENER DIODE EDZTE618.2B QD1B00EDZ8R2 R791 CHIP RES. 1/10W J 82k Ω RRXAJR5Z0823 D702 ZENER DIODE EDZTE618.2B QD1B00EDZ8R2 R792 CHIP RES. 1/10W J 100k Ω RRXAJR5Z0104 D703 ZENER DIODE EDZTE618.2B QD1B00EDZ8R2 R793 CHIP RES. 1/10W J 100k Ω RRXAJR5Z0104 D704 ZENER DIODE EDZTE618.2B QD1B00EDZ8R2 R794 CHIP RES. 1/10W J 100k Ω RRXAJR5Z0104 D705 DIODE ZENER 8V2BSB-T26 NDTB8R2BST26 R795 CHIP RES. 1/10W J 100k Ω RRXAJR5Z0104 D706 DIODE ZENER 8V2BSB-T26 NDTB8R2BST26 R796 CHIP RES. 1/10W J 2.2k Ω RRXAJR5Z0222 D707 ZENER DIODE EDZTE618.2B QD1B00EDZ8R2 R797 CHIP RES. 1/10W J 2.2k Ω RRXAJR5Z0222 D708 ZENER DIODE EDZTE618.2B QD1B00EDZ8R2 R843 CHIP RES. 1/10W J 110 Ω RRXAJR5Z0111 D709 DIODE ZENER 8V2BSB-T26 NDTB8R2BST26 R844 CHIP RES. 1/10W J 220 Ω RRXAJR5Z0221 D710 ZENER DIODE EDZTE618.2B QD1B00EDZ8R2 R845 CHIP RES. 1/10W J 100k Ω RRXAJR5Z0104 R846 CHIP RES. 1/10W J 100 Ω RRXAJR5Z0101 IC771 IC SWITCHING TC4052BF(ELNF) R847 CHIP RES. 1/10W J 10k Ω RRXAJR5Z0103 R848 CHIP RES. 1/10W J 10k Ω RRXAJR5Z0103 IC QSZBA0TTS162 COILS L851 WIRE CP STP-S-0.50 XZ40F0REN001 R851 RES CARBON FILM T 1/4W J 180 Ω RCX4181T1001 L852 WIRE CP STP-S-0.50 XZ40F0REN001 R852 RES CARBON FILM T 1/4W J 180 Ω RCX4181T1001 L853 WIRE CP STP-S-0.50 XZ40F0REN001 BC771 BEADS INDUCTOR FBR07HA121SB-00 LLBF00STU030 Q722 TRANSISTOR KTC3199-GR-AT/P NQS4KTC3199P BC841 CHIP INDUCTOR BK1608HS601-T LLC601NTU017 Q771 TRANSISTOR KTC3199-GR-AT/P NQS4KTC3199P JK711 JACK HPEP SML PCB S PJ-358H JXSJ020YUQ01 Q773 TRANSISTOR KTC3199-GR-AT/P NQS4KTC3199P JK721 JACK RCA PCB S WHITE 01/RCA-101H(WH) JXRJ010YUQ02 Q774 TRANSISTOR KTC3199-GR-AT/P NQS4KTC3199P JK722 JACK RCA PCB S RED 01/RCA-101H(RD) JXRJ010YUQ01 Q841 TRANSISTOR KTC3199-GR-AT/P NQS4KTC3199P JK731 JACK RCA PCB S GREEN 01/RCA-101H(GN) JXRJ010YUQ03 JK732 JACK RCA PCB S BLUE 01/RCA-101H(BL) JXRJ010YUQ04 JXRJ010YUQ01 TRANSISTORS RESISTORS R711 MISCELLANEOUS CHIP RES. 1/10W J 100k Ω RRXAJR5Z0104 JK733 JACK RCA PCB S RED 01/RCA-101H(RD) R712 CHIP RES. 1/10W J 100k Ω RRXAJR5Z0104 JK741 JACK RCA PCB S WHITE 01/RCA-101H(WH) JXRJ010YUQ02 R717 CHIP RES. 1/10W J 56k Ω RRXAJR5Z0563 JK742 JACK RCA PCB S RED 01/RCA-101H(RD) JXRJ010YUQ01 R718 CHIP RES. 1/10W J 56k Ω RRXAJR5Z0563 JK752 JACK RCA PCB L RCA-141-01 JXRL01YUQ005 R721 CHIP RES. 1/10W J 100k Ω RRXAJR5Z0104 JK753 JACK RCA PCB L RCA-101S(1)-04 JXRL010YUQ13 JYRL010YUQ05 R722 CHIP RES. 1/10W J 100k Ω RRXAJR5Z0104 JK754 JACK SW RCA PCB L RCA-102F(RD) R727 CHIP RES. 1/10W J 56k Ω RRXAJR5Z0563 JK841 JACK RCA PCB S ORANGE 01/RCA-101H(OR) JXRJ010YUQ06 R728 CHIP RES. 1/10W J 56k Ω RRXAJR5Z0563 JK851 JACK SW HPEP SML PCB L PJ-350 JYSL010YUQ03 R731 CHIP RES.(1608) 1/10W F 75 Ω RRXAFR5H75R0 JS701 CHIP RES.(1608) 1/10W 0 Ω RRXAZR5Z0000 R732 CHIP RES.(1608) 1/10W F 75 Ω RRXAFR5H75R0 R733 CHIP RES.(1608) 1/10W F 75 Ω RRXAFR5H75R0 R734 CHIP RES. 1/10W J 10 Ω RRXAJR5Z0100 R735 CHIP RES. 1/10W J 10 Ω RRXAJR5Z0100 R736 CHIP RES. 1/10W J 10 Ω RRXAJR5Z0100 R741 CHIP RES. 1/10W J 100k Ω RRXAJR5Z0104 R742 CHIP RES. 1/10W J 100k Ω RRXAJR5Z0104 R747 CHIP RES. 1/10W J 56k Ω RRXAJR5Z0563 R748 CHIP RES. 1/10W J 56k Ω RRXAJR5Z0563 R753 CHIP RES. 1/10W J 75 Ω RRXAJR5Z0750 R754 CHIP RES. 1/10W J 100k Ω RRXAJR5Z0104 R755 CHIP RES. 1/10W J 100k Ω RRXAJR5Z0104 2011/05/11 FUNCTION CBA Ref. No. Description FUNCTION CBA(MJC-B) Consists of the following: Part No. ---------- CAPACITORS C103 ELECTROLYTIC CAP. 47µF/16V M H7 CE1CMAVSL470 C104 CHIP CERAMIC CAP. B K 330pF/50V CHD1JK30B331 C107 CHIP CERAMIC CAP. (1608) F Z 1µF/16V CHD1CZ30F105 C108 CAP CERAMIC (AX) 0.1µF/50V/F/Z CA1J104TU062 C109 CAP CERAMIC (AX) 0.1µF/50V/F/Z CA1J104TU062 14-16 A17N2EL.fm Ref. No. Description Part No. DIODES D101 ZENER DIODE EDZTE61 6.8B QD1B00EDZ6R8 D103 LED L-53HT NP4Z000L53HT D104 LED GREEN 333GT/E(FNA) NPWZ33GTEFNA D105 CAP CERAMIC (AX) 0.1µF/50V/B/K CA1J104TU061 R106 RES CARBON FILM T 1/4W J 100 Ω RCX4101T1001 R107 CHIP RES. 1/10W J 3.3k Ω RRXAJR5Z0332 R108 CHIP RES. 1/10W J 220 Ω RRXAJR5Z0221 R109 CHIP RES. 1/10W J 220 Ω RRXAJR5Z0221 R110 CHIP RES. 1/10W J 1k Ω RRXAJR5Z0102 R111 CHIP RES. 1/10W F 18k Ω RRXAFR5H1802 RESISTORS R112 CHIP RES. 1/10W F 13k Ω RRXAFR5H1302 R113 CHIP RES. 1/10W F 2.7k Ω RRXAFR5H2701 R114 CHIP RES. 1/10W F 2.2k Ω RRXAFR5H2201 R115 CHIP RES. 1/10W F 2.2k Ω RRXAFR5H2201 R116 RES CARBON FILM T 1/4W J 220 Ω RCX4221T1001 R118 CHIP RES. 1/10W F 10k Ω RRXAFR5H1002 SW104 TACT SWITCH SKHHLMA010 SST0101AL049 SW105 TACT SWITCH SKHHLMA010 SST0101AL049 SW106 TACT SWITCH SKHHLMA010 SST0101AL049 SW107 TACT SWITCH SKHHLMA010 SST0101AL049 SW108 TACT SWITCH SKHHLMA010 SST0101AL049 SW109 TACT SWITCH SKHHLMA010 SST0101AL049 SWITCHES MISCELLANEOUS CL101 WIRE ASSEMBLY 8PIN 8PIN/100MM/AWG 26 RS101 SENSOR REMOTE RECEIVER KSM-712TH2E USESJRSKK044 2011/05/11 WX1A01N0-001 14-17 A17N2EL.fm TYPE C PARTS LIST [19ME601B/F7(Serial No.: DS2)] Mechanical Parts PRODUCT SAFETY NOTE: Products marked with a # have special characteristics important to safety. Before replacing any of these components, read carefully the product safety notice in this service manual. Don't degrade the safety of the product through improper servicing. NOTE: Parts that are not assigned part numbers (---------) are not available. Ref. No. Description STAND ASSEMBLY A1170UH Ref. No. Description Part No. S5 SET BAG A81N0UH 1EM323958A S6 SERIAL NO. LABEL A01PBUH ---------- S7 POLYETHYLENE BAG HDPE 180X340XT0.03 1EM435579 ACCESSORIES X1 POLYETHYLENE BAG HDPE 180X340XT0.03 1EM435579 X2# OWNERS MANUAL A1170UH 1EMN28066 X3 REMOTE CONTROL NF805UD NF805UD X4 DRY BATTERY R03/2S XB0M451T0006 X6 QUICK START GUIDE A1170UH 1EMN28067 X7 REGISTRATION CARD (MAGNAVOX) A17N0UH 1EMN27759 Part No. 1ESA28505 A1 FRONT CABINET A11N0UH 1EM027625 A2 REAR CABINET A11N0UH 1EM027626 A8 JACK HOLDER A17N1UH 1EM225424 A10 CONTROL PLATE A11N0UH 1EM330577 A11 SENSOR LENS A11N0UH 1EM226005 A12# RATING LABEL A11N5UH ---------- A15 ENERGY STAR LABEL A91F2UH ---------- A40 LED LENS A11N0UH 1EM226006 A42 ENERGY GUIDE LABEL A11N5UH ---------- AC601# AC CORD W/O A GND WIRE UL/CSA/1700/NO/ WAC1720LW005 BLACK B5 STAND BRACKET A11N0UH 1EM226007 B18 GASKET A8AF0UH 1EM425861 B22 WALL MOUNT BRACKET A11N0UH 1EM434637 B27 CLOTH(10X180XT0.5) L0336JG 0EM408827 B32 SENSOR SHIELD A11N0UH 1EM330637 B47 WALL MOUNT COVER A11N0UH 1EM330718 B48 MODULE SPACER A11N0UH 1EM330638 CL601 FFC WIRE ASSEMBLY 19PIN 19PIN/75MM WX1A11N5-102 CL1001 FFC WIRE ASSEMBLY 6PIN 6PIN/228MM WX1A11N5-101 CL3006 FFC WIRE 30PIN 30PIN/138MM WX1A11N5-103 CL3102 WIRE ASSEMBLY 7PIN 7PIN/280MM/RED/ BLACK WX1A11N5-201 CL3103 WIRE ASSEMBLY 2PIN 2PIN/90MM/RED/ BLACK WX1A11N5-205 CL3801 WIRE ASSEMBLY 2PIN 2PIN/75MM/RED/ BLACK WX1A11N5-203 CL3802 WIRE ASSEMBLY 2PIN 2PIN/145MM/RED/ BLACK WX1A11N5-204 CL4051 WIRE ASSEMBLY 3PIN 3PIN/43MM/RED/ BLACK WX1A11N5-202 L14 SCREW S-TIGHT M3X6 BIND HEAD+ GBJS3060 L16 SCREW P-TIGHT 3X12 BIND HEAD+ BLK GBHP3120 L25 S-TIGHT SCREW M3X6 BIND HEAD+BLACK GBHS3060 L28 STAND SCREW KIT A1170UH 1ESA28511 LCD1 LCD MODULE 18.5INCH 18.5INCH UK19MXB SP3801 SPEAKER MAGNETIC 8OHM/3.5W S0307F06A DS08070XQ003 SP3802 SPEAKER MAGNETIC 8OHM/3.5W S0307F06A DS08070XQ003 S1 CARTON A11N5UH 1EM434937 S3 STYROFOAM TOP A11N0UH 1EM027745 S4 STYROFOAM BOTTOM A11N0UH 1EM027746 PACKING 2011/05/11 14-18 A11N5CA.fm Electrical Parts PRODUCT SAFETY NOTE: Products marked with a # have special characteristics important to safety. Before replacing any of these components, read carefully the product safety notice in this service manual. Don't degrade the safety of the product through improper servicing. Ref. No. Description Part No. C1015 CHIP CERAMIC CAP.(1608) B K 4.7µF/6.3V CHD0KK30B475 C1016 CHIP CERAMIC CAP.(1608) B K 1000pF/50V CHD1JK30B102 C1017 CHIP CERAMIC CAP.(1608) F Z 0.1µF/50V CHD1JZ30F104 C1018 CERAMIC CAP. 100pF/2KV CA3D101PAN04 C1020 CHIP CERAMIC CAP.(3216) X7R K 1.0µF/100V CA2A105MR080 CN601 FMN CONNECTOR TOP 19P IMSA-9615S-19A- JC96J19ER007 PP-A CN603# VH CONNECTOR PRINT OSU B2P3SVH(LF)(SN) J3VH030JG002 CN1001 FFC CONNECTOR 6P IMSA-9615S-06C-PP-A JC96J06ER009 CONNECTORS NOTES: 1. Parts that are not assigned part numbers (---------) are not available. 2. Tolerance of Capacitors and Resistors are noted with the following symbols. C.....±0.25% G.....±2% M.....±20% D.....±0.5% J......±5% N.....±30% DIODES F.....±1% K.....±10% Z.....+80/-20% DIGITAL ASSEMBLY Ref. No. Description Part No. DIGITAL ASSEMBLY Consists of the following A11N5MMA-001 DIGITAL MAIN CBA UNIT FUNCTION CBA UNIT IR SENSOR CBA UNIT LED CBA UNIT A11N5MMA-001-DM A11N5MMA-001-FN A11N5MMA-001-IR A11N5MMA-001-LE MAIN CBA Ref. No. Description MAIN CBA Consists of the following Part No. A1170MPW-001 CAPACITORS D601 DIODE ZENER 1ZB220-YBB D608 DIODE ZENER 10BSB-T26 NDWZ01ZB220Y NDTB010BST26 D609 DIODE 1N5397BD NDL1001N5397 D610 DIODE 1N5397BD NDL1001N5397 D611 DIODE 1N5397BD NDL1001N5397 D612 DIODE 1N5397BD NDL1001N5397 D613 DIODE ZENER 4V3BSB-T26 NDTB4R3BST26 D614 DIODE ZENER 27BSB-T26 NDTB027BST26 D615 DIODE ZENER 1ZB36BB NDWZ0001ZB36 D616 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 D618 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 D619 DIODE SHOTTKY SB3200BR NDWZ3200D027 D620 DIODE ZENER 1ZB30BB NDWZ0001ZB30 D627 DIODE SK16-T/R ND1Z0000SK16 D629 DIODE SCHOTTKY SMD SK2B-TR ND1Z00SK2BTR D630 DIODE ZENER 1ZB20BB NDWZ0001ZB20 D634 DIODE ZENER 5V6BSB-T26 NDTB5R6BST26 D635 DIODE ZENER 3V3BSB-T26 NDTB3R3BST26 D636 DIODE ZENER 5V6BSB-T26 NDTB5R6BST26 D637 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 D640 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 C607# CAP METALIZED FILM 0.47µF/300V K 3.5MM CT2F474DC004 D641 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 C608 CAP ELE 220µF/200V/M/85 CEB2210S6016 D642 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 C610 CHIP CERAMIC CAP. B K 0.039µF/50V CHD1JK30B393 D657 DIODE SK16-T/R ND1Z0000SK16 C611 CHIP CERAMIC CAP. B K 1200pF/50V CHD1JK30B122 D658 DIODE ZENER 5V6BSB-T26 NDTB5R6BST26 C612 CERAMIC CAP. 820pF/2KV CA3D821PAN04 D660 DIODE ZENER 4V7BSB-T26 NDTB4R7BST26 C613 CHIP CER. BK 0.082µF/50V CHD1JK30B823 D661 DIODE FAST RECOVERY SMD GR1G ND1Z00GR1GTR C614 CHIP CERAMIC CAP.(1608) B K 1000pF/50V CHD1JK30B102 D662 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 C616 ELECTROLYTIC CAP. 470µF/25V M CE1EMASDL471 D663 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 C617 CERAMIC CAP. 1500pF/2KV CA3D152PAN04 D664 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 C622 ELECTROLYTIC CAP. 220µF/10V M CE1AMASDL221 D665 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 C623 ELECTROLYTIC CAP. 470µF/25V M CE1EMASDL471 D1001 DIODE SCHOTTKY SB1A0BB NDWZ000SB1A0 C625 CHIP CERAMIC CAP. B K 2200pF/50V CHD1JK30B222 D1002 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 C626# SAFTY CAP. 2200pF/250V KX CA2E222MR101 D1004 DIODE ZENER 27BSB-T26 NDTB027BST26 C627# SAFTY CAP. 1000pF/250V KX CA2E102MR101 D1005 SWITCHING DIODE 1SS133(T-77) QDTZ001SS133 C630 ELECTROLYTIC CAP. 1µF/50V M CE1JMASDL1R0 C632 ELECTROLYTIC CAP. 470µF/25V M CE1EMASDL471 IC601# IC PHOTOCOUPLER TLP781F(D4-FUNBLL F) C633 ELECTROLYTIC CAP. 470µF/25V M CE1EMASDL471 IC1001 C1001 CHIP CERAMIC CAP.(1608) B K 1µF/25V CHD1EK30B105 IC LED BACKLIGHT CONTROLLER HA7202PC NSCA0T00H001 /SOP /24PIN C1002 CHIP CERAMIC CAP.(1608) B K 1µF/25V CHD1EK30B105 C1003 ELECTROLYTIC CAP. 330µF/25V M CE1EMASDL331 L601# LINE FILTER 27H-9014/5MH LLEG0ZDEL003 C1004 CHIP CERAMIC CAP.(1608) B K 1µF/25V CHD1EK30B105 L1001 LLF4700SF012 C1005 CHIP CERAMIC CAP.(3216) X7R K 1.0µF/100V CA2A105MR080 COIL POWER INDUCTORS DIP RCR1010NP470M/47µH C1006 CHIP CERAMIC CAP.(3216) X7R K 1.0µF/100V CA2A105MR080 Q607# MOS FET TK5A50D(LS1FND.Q)/Z QEEZTK5A50DQ Q608 TRANSISTOR 2SC2120-Y(TE2 F T) QQSY2SC2120F Q609 CHIP TRANSISTOR 2SC2412K(R) T146 QQ8R2SC2412K Q610 CHIP TRANSISTOR 2SC2412K(R) T146 QQ8R2SC2412K C1010 C1011 C1012 C1013 ELECTROLYTIC CAP. 47µF/100V M CHIP CERAMIC CAP.(1608) B K 1000pF/50V CHIP CERAMIC CAP. B K 470pF/50V CHIP CERAMIC CAP.(1608) B K 0.47µF/16V 2011/05/11 CE2AMASDL470 CHD1JK30B102 CHD1JK30B471 CHD1CK30B474 ICS QPEL781FBLLF COILS TRANSISTORS 14-19 A11N5EL.fm Ref. No. Description Ref. No. Part No. Description Part No. RES CHIP 1608 1/10W J 10k Ω RRXA103HH013 R1022 RES CHIP 1608 1/10W J 100k Ω RRXA104HH013 R1023 RES CHIP 1608 1/10W J 1.0k Ω RRXA102HH013 QQ8R2SC2412K R1030 RES CARBON FILM T 1/4W J 18k Ω RCX4183T1001 QF1ZSD050N10 R1031 RES CARBON FILM T 1/4W J 18k Ω RCX4183T1001 R1032 RES CHIP 1608 1/10W J 240 Ω RRXA241HH013 R1033 RES CHIP 1608 1/10W J 240 Ω RRXA241HH013 Q611 TRANSISTOR KTC3198-Y-AT/P NQSYKTC3198P R1021 Q615 CHIP TRANSISTOR 2SC2412K(R) T146 QQ8R2SC2412K Q616 CHIP TRANSISTOR 2SC2412K(R) T146 QQ8R2SC2412K Q631 CHIP TRANSISTOR 2SC2412K(R) T146 Q1001 FET MOS RSD050N10TL RESISTORS R623 RES CHIP 1608 1/10W J 22k Ω RRXA223HH013 R624 RES CHIP 1608 1/10W J 22k Ω RRXA223HH013 MISCELLANEOUS R625# GLASS GLAZE RES. 1/2W J 1M Ω RXX2JZLZ0105 B62 HEAT SINK PNI A11N5UH 1EM435557 R626 RES CEMENT 3W J 1.2 Ω RWJ1R2PAK004 BC001 BEADS INDUCTOR FBR07HA121SB-00 LLBF00STU030 R627 CHIP RES. 1/4W J 390k Ω RRX4JR7Z0394 BC601 BEADS INDUCTOR FBR07HA121SB-00 LLBF00STU030 R628 CHIP RES. 1/4W J 390k Ω RRX4JR7Z0394 BC1001 BEADS INDUCTOR FBR07HA121SB-00 LLBF00STU030 R629 CHIP RES. 1/4W J 390k Ω RRX4JR7Z0394 BC1002 BEADS INDUCTOR FBR07HA121SB-00 LLBF00STU030 R630 CHIP RES. 1/4W J 390k Ω RRX4JR7Z0394 F601# FUSE STC4A125V U/CT PAGE20CW3402 R631 RES CARBON FILM T 1/4W J 330 Ω RCX4331T1001 FH601 FUSE HOLDER MSF-015 LF (B110) XH01Z00LY002 R632 RES CARBON FILM T 1/4W J 330 Ω RCX4331T1001 FH602 FUSE HOLDER MSF-015 LF (B110) XH01Z00LY002 R633 RES CARBON FILM T 1/4W J 1.2k Ω RCX4122T1001 JS1001 WIRE CP STP-S-0.50 XZ40F0REN001 R634# METAL OXIDE FILM RES. 2W J 0.68 Ω RN02R68ZU001 L3 SCREW B-TIGHT D3X8 BIND HEAD+ GBJB3080 R635 RES CARBON FILM T 1/4W J 2.2k Ω RCX4222T1001 SA601# SURGE ABSORBER 470V+-10PER NVQZ10D471KB R636 RES CARBON FILM T 1/4W J 220 Ω RCX4221T1001 T601# TRANS POWER 11706 LTT2PC0KT070 R639 RES CARBON FILM T 1/4W J 1.5k Ω RCX4152T1001 R642 RES CARBON FILM T 1/4W J 270 Ω RCX4271T1001 R643 RES CARBON FILM T 1/4W J 3.9k Ω RCX4392T1001 R645 RES CHIP 1608 1/10W F 18.0k Ω RTW1802HH008 R646 RES CHIP 1608 1/10W F 820 Ω RTW8200HH008 R647 RES CHIP 1608 1/10W F 22.0k Ω RTW2202HH008 R648 RES CHIP 1608 1/10W F 24.0k Ω RTW2402HH008 R649 RES CHIP 1608 1/10W 0 Ω RRXA000HH014 R650 RES CHIP 1608 1/10W 0 Ω RRXA000HH014 R652 RES CHIP 1608 1/10W J 47k Ω RRXA473HH013 R653 RES CHIP 1608 1/10W J 10k Ω RRXA103HH013 R654 RES CARBON FILM T 1/4W J 220 Ω RCX4221T1001 R655 RES CARBON FILM T 1/4W J 220 Ω RCX4221T1001 R656 RES CARBON FILM T 1/4W J 15 Ω RCX4150T1001 R657 WIRE CP STP-S-0.50 XZ40F0REN001 R661 RES CARBON FILM T 1/4W J 220 Ω RCX4221T1001 R673 RES CHIP 1608 1/10W J 1.0 Ω RRXA1R0HH013 R674 RES CHIP 1608 1/10W F 22.0k Ω RTW2202HH008 R675 RES CHIP 1608 1/10W F 30.0k Ω RTW3002HH008 R677 RES CARBON FILM T 1/4W J 22k Ω RCX4223T1001 R678 RES CHIP 1608 1/10W J 47k Ω RRXA473HH013 R679 RES CHIP 1608 1/10W J 10k Ω RRXA103HH013 R680 RES CARBON FILM T 1/4W J 270 Ω RCX4271T1001 R681 RES CARBON FILM T 1/4W J 270 Ω RCX4271T1001 R682 RES CARBON FILM T 1/4W J 220 Ω RCX4221T1001 R684 RES CHIP 1608 1/10W J 56k Ω RRXA563HH013 R685 RES CHIP 1608 1/10W J 6.8k Ω RRXA682HH013 R686 RES CHIP 1608 1/10W J 10k Ω RRXA103HH013 R687 RES CHIP 1608 1/10W J 2.7k Ω RRXA272HH013 R1002 RES CHIP 1608 1/10W F 560k Ω RTW5603HH008 R1003 RES CHIP 1608 1/10W F 360k Ω RTW3603HH008 R1004 RES CHIP 1608 1/10W F 27.0k Ω RTW2702HH008 R1005 RES CHIP 1608 1/10W 0 Ω RRXA000HH014 R1006 RES CHIP 1608 1/10W J 10 Ω RRXA100HH013 R1007 METAL OXIDE RES. 1W J 0.24 Ω RN01R24ZU001 R1009 RES CHIP 1608 1/10W F 20.0k Ω RTW2002HH008 RTW1501HH008 R1010 RES CHIP 1608 1/10W F 1.50k Ω R1011 RES CHIP 1608 1/10W F 100k Ω RTW1003HH008 R1012 RES CHIP 1608 1/10W J 100 Ω RRXA101HH013 R1013 RES CHIP 1608 1/10W F 100 Ω RTW1000HH008 R1019 RES CHIP 1608 1/10W J 10k Ω RRXA103HH013 R1020 RES CHIP 1608 1/10W J 100k Ω RRXA104HH013 2011/05/11 14-20 A11N5EL.fm REVISION HISTORY Chassis FL11.0 • 2011-02-14 LC190EM2 (Serial No. : TH1) added • 2011-02-14 LC190SS2 (Serial No. : TH1) added • 2011-04-20 19MF301B/F7 (Serial No. : TH1) added • 2011-04-20 LC190EM2 (Serial No. : TH2) added • 2011-05-13 19ME601B/F7 (Serial No. : DS2) added 15-1 FL11.0REV COMPARISON LIST OF MODEL NAME Chassis FL11.0 19MF301B/F7 LC190EM2 (TH1) A17N7UT (TH1) A17N5UT (TH2) A17N8UT LC190SS2 (TH1) A17N2UT 19ME601B/F7 (DS2) A11N5UH FL11.0COM