Download BLUE EMBER GRILLS FGQ65079 Specifications
Transcript
BLUE EMBER GRILLS ~ GAS GRILLS Outdoor Gas Barbeque/GriII Assembly manual .andUse,and,~Care· '•• ··;{>";~~fk~b];;~lj;~j:;·:··:,·,: . : A WARNING! Hazardous Fire or Explosion may result if these instructions are ignored. IF YOU SMELL GAS: It is your responsibility to see that your new barbeque is assembled, installed, maintained and cared for properly. Failing to carefully follow the instructions in this manual could result in serious bodily injury and/or property damage, Any modification to the barbeque is dangerous and is not permitted. WARRANTY INFORMATION Full Model No. from outer carton: Date Purchased: Serial Number (from rating plale): _ _ _ SAVE THIS MANUAL FOR FUTURE REFERENCE Installer must leave instructions with the consumer for future reference. KEEP YOUR RECEIPT AS PROOF OF PURCHASE TO VALIDATE THE WARRANTY. ATTACH YOUR RECEIPT TO THE INSIDE COVER OF THIS MANUAL FOR EASY REFERENCE. MANUFACTURED FOR: Fiesta Gas Grills, LLC. One Fiesta Drive Dickson, TN USA 37055 Distributed by Home Depol U.S.A., Inc. 2455 Paces Ferry Rd., N.W. Allanla, GA 30339 1·800·396-3838 © 2004 Homer nc, Inc. All Rlghls Reserved. 1. 2. 3. 4. Shut off gas supply to the appliance. Extinguish any open flame. Open lid. If odor continues, keep away from the appliance and immediately call your gas supplier or your fire department. Do not store or use gasoline or other flammable liquids or vapors in the vicinity of this or any other appliance. 2. An lP cylinder not connected for use shall not be stored in the vicinity of this or any other appliance. THANK YOU FOR PURCHASING THIS BARBEQUE FOR RESIDENTIAL USE ONLY. DO NOT USE FOR COMMERCIAL COOKING. We are dedicated to creating the ultimate barbeque experience by providing you with all the right tools, starting with this manual. It is important to read through the entire booklet prior to using your barbeque to ensure you fully understand all of the features and how to operate your barbeque for optimum performance. Combustion by-products produced when using this product contain chemicals known to the state of California to cause cancer, birth defects, or other reproductive harm. SAFETY SYMBOLS The symbols and boxes shown below explain what each heading means. Read and follow all of the messages found throughout the manual. Please retain this manual for the lifetime of your barbeque after recording the serial and model number in the appropriate space allocated on the front cover. DANGER: INDICATES AN IMMINENTLY HAZARDOUS SITUATION WHICH, IF NOT AVOIDED, WILL RESULT IN DEATH OR SERIOUS INJURY. • The serial number can be found on the silver rating plate located on rear of the bottom pan resin. Serial numbers are 9 digits long e.g. 08U123456 WARNING: INDICATES AN POTENTIALLY HAZARDOUS SITUATION WHICH, IF NOT AVOIDED, COULD RESULT IN DEATH OR SERIOUS INJURY. • The full model number can be found on the white label of your barbeque box or above the serial number on the silver rating plate. CAUTION: INDICATES AN POTENTIALLY HAZARDOUS SITUATION, OR UNSAFE PRACTICE WHICH, IF NOT AVOIDED, COULD RESULT IN MINOR OR MODERATE INJURY. TABLE OF CONTENTS Getting Familiar With Your Barbeque •.•3 FOR YOUR OWN SAFETY, PRIOR TO EACH USE: • Only use your barbeque OUTDOORS in a well-ventilated area and shall not be used in abuilding garage or any other enclosed area preferably 3m (10 feet) from your residence or any outbuildings. • Always keep the area around your barbeque clear of any combustible materials, gasoline, or other flammable liqUids. • Keep the ventilation opening(s) of the cylinder enclosure free and clear from debris. • DO NOT operate this barbeque under overhead or unprotected combustible construction. • DO NOT obstruct the flow of combustion and ventilation air to the barbeque. • DO NOT use in garages, sheds, breezeways, or other enclosed areas. • DO NOT store aspare L.P. (propane) cylinder under or near your barbeque. • DO NOT leave your barbeque unattended While in operation. • DO NOT allow children to operate or play near your barbeque. • DO NOT use while under the influence of alcohol or drugs. • DO NOT install/use in or on recreational vehicles and/or boats Caring For Your Equipment •..•...•..•3 Installation Electrical Caution L.P. Gas Cylinder Hose &Regulator Cleaning & Maintenance 7 Perform A Leak Test Cleaning Venturi Tubes Cleaning Other Parts of Your Appliance Storage Using Your Appliance Correctly ..•.....9 Getting Familiar with the Controls Lighting Re-Lighting Shutting Down Breaking In Your Barbeque Cooking Techniques Providing Power to your Barbeque DO NOT USE CHARCOAL OR CERAMIC BRIQUETS IN THIS GAS GRILL, THEY ARE NOT REQUIRED. IF THE ABOVE INSTRUCTIONS ARE NOT FOLLOWED EXACTLY, AFIRE CAUSING DEATH OR SERIOUS INJURY MAY OCCUR. Trouble Shooting Guide •••..••......15 Warranty Information ..••.........•.16 2 DO NOT USE YOUR BARBEQUE UNTIL YOU HAVE READ AND UNDERSTOOD ALL THE INFORMATION IN THIS MANUAL. IT IS EXTREMELY IMPORTANT TO BE SURE THAT: BEFORE YOU USE THIS APPLIANCE • Your barbeque is properly assembled. • There are no leaks in the gas supply system (see 'Leak Testing section). • The burner is properly assembled with the venturi tubes seated over the valve outlets (Figure 1) and there are no blockages present in the venturi tubes (see Cleaning Venturi Tubes' Seclion). • All electrical supply cords and/or gas supply hoses are kept away from all or any heated surfaces. • Your barbeque is positioned in a safe location (see 'Inslallalion' section). Figure 2. • Ensure valve outlets (orifices) are assembled 1 cm (3/8") into the venturi tubes. • Check to see that the valve outlets and venturi tubes are parallel to the bottom of the base casting of your appliance. VENTURI TUBE FAILURE TO ENSURE THE ABOVE MAY RESULT IN AHAZARDOUS FIRE OR EXPLOSION CAUSING SERIOUS BODILY INJURY AND/OR PROPERTY DAMAGE. CARING FOR YOUR EQUIPMENT INSTALLATION WHEN DECIDING WHERE TO PLACE YOUR APPLIANCE, FOLLOW TtESE MINIMUM CLEARANCE DISTANCES TO ADJACENT COMBUSTIBLE MATERIALS: THE INSTALLATION OF THIS APPLIANCE MUST CONFORM WITH LOCAL CODES OR, IN THE ABSENCE OF LOCAL CODES: • with either the National Fuel Gas Code ANSI Z223.1/NFPA 54, Natural Gas and Propane Installation Code, CSA B149.1, or Propane Storage and Handling Code, B149.2, or the Standard for Recreational Vehicles, ANSI A 119.2/NFPA 119.2, and CSA Z240 RV Series, Recreational Vehicle Code, as applicable. • Handling and storage of LP cylinders must conform to LP Gas Code NFPAlANSI 58. Grill is not for use in or on recreational vehicles and/or boats. • All electrical accessories (such as rotisserie) must be electrically grounded in accordance with local codes, or National Electrical Code, ANSI/NFPA 70. Keep any electrical cords and/or fuel supply hoses away from any hot surfaces. • This grill is safety certified for use in the United States and Canada Only. Do not modify for use in any other location. Modification will result in a safety hazard. • 61 cm (24 inches) • 46 cm (18 inches) from side of unit from back of unit (See Figure 2) (See Figure 2) APARTMENT DWELLERS Check with management to learn the requirements and fire codes for using an LP gas grill in your apartment complex. If allowed, use outside on the ground floor with clearances as stated in Figure 2 from walls or rails. Do not use on or under balconies. MODEL MAY NOT BE EXACTLY AS SHOWN. DO NOT USE TillS GAS OUTDOOR APPLIANCE UNDER ANY OVERHEAD COMBUSTIBLE CONSTRUCTION. 3 CARING FOR YOUR EQUIPMENT PROVIDING POWER TO YOUR BARBEQUE ELECTRICAL CAUTION • If any accessory installed on this barbeque requires an external electrical power source, it must be electrically grounded in accordance with local laws or in the absence of local laws, with the Canadian Electrical Code CSA C22.1 or in the U.S., with the National Electrical Code ANSI-NFPA 70. • The three-prong plug provides protection against shock hazard and should be plugged directly into a properly grounded three-prong receptacle. Do not cut or remove the grounding prong from this plug. • To ensure continued protection against risk of electric shock, connect to properly earthed outlets only. • Ensure all electrical supply cords and fuel supply hoses are kept well away from any heated surfaces. L.P.GAS CYLINDER Gas cylinders manufactured today have mechanisms to provide worry free barbequing year round: Q.C.C.1 or Type 1-Quick Connect Coupling Valve, ensure fast tank hookups requiring only hand tightening. The redundant valve system inhibits the flow of gas to the burner if the connection is not 100% correct. a.p.D. or Overlill Protection Device prevents accidental gas leaks caused by cylinder "over pressurization", the leading cause of cylinder gas leaks. The float in the tank will automatically stop filling at 80% capacity, leaving a20% area for the expansion of liquid. Without this safety feature, the relief valve may open and discharge propane, creating a potential safety hazard. An O.P.D. cylinder is easily distinguished by its triangular hand wheel valve. Figure 3) liAS ~ IiURRDIAn™ NEWOPD HANDWHEEL Look for the Gas Guardian symbol to easily Identify propane cylinders with these safety features. 1. SPECIFICATIONS Self-contained propane gas barbeque systems are designed to be used only with a9.1 kg (20 Ib) propane cylinder, equipped with a Type 1 cylinder valve and incorporating an overfill protection device (O.P.D). This barbeque cannot be connected to an existing #510 P.O.L. type valve (ones with left-hand threads). The cylinder for your gas barbeque must be constructed and marked in accordance with the specifications of L.P. gas cylinders: , Plug electrical cord into properly grounded GFI (Ground Fault Interrupt) receptacle. If use of an extension cord is required, be sure that it is a minimum 16 AWG, 3 wire -.......''-IN..... well insulated cord, marked for OUTDOOR , USE ONLY and properly grounded. (Fig.14) CAUTION: To ensure continued protection against risk of electric shock, connect to properly earthed outlets only. CONNECTION DEVICE. The Type 1valve is recognizable by the large external thread on the outlet part of the valve. Standard existing valves do not have these exterior threads. Any attempt to connect aregulator, with other than the: i) Mating Type 1connector (recognized by the large black coupling nut) or ii) Standard #510 P.O.L. fitting, by use of adapters or any other means, could result in damage, fire or injury and may negate the important safety features designed into the Type 1 system. The connection of a#510 P.O.L. fitting will not provide the flow control or temperature shut-off features buill into the complete Type 1system. We strongly reconvnend use of a propane cylinder with Q.C.C.I aid O.P.D. safety features. THE CYLINDER MUST AlSO BE EQIDPPED WITH: a. Ashut-off valve terminating in a proper cylinder valve outlet specified in current standards: o Canada: CAN/GGA - 1.6a - M98 - Outdoor Gas Grills - Amend. o U.S.: ANSI Z21.58a-1998 OUTDOOR COOKING APPLIANCES. b. Alisted overfilling protection device (O.P.D.). c. Asafety relief valve having direct communication with the vapor space of the cylinder. d. Acollar to protect the tank shut off valve. e. An arrangement for vapor withdrawal. f. Abottom ring for securing to tank support assembly. THE CYLINDER SHOULD NOT EXCEED 472 MM (18112'1 IN HEIGHT AND 317 MM (121/2'1 IN DIAMETER. o /~", ,,',;or-- :'/ To provide power to the barbecue, plug grounded electrical cord into rear electrical box as shown. Page 14 (Fig.15) FLOAT FILLING STOPS AT 80% In Canada: The National Standards of Canada CAN/CSA-B339, Cylinders, Spheres and Tubes for Transportation of Dangerous Goods; and Commission. In the U.S.: U.S. Department of Transportation (D.O.T.) SAFETY: Always turn off the cylinder valve tightly when your barbeque is not in use. Handle tank valves with care. Never connect an unregulated L.P. gas cylinder to your barbeque. • Never store aspare cylinder under or near your barbeque when in use. o Never subject any cylinder to excessive heat or direct sunlight. o Always keep your in-use cylinder securely fastened in an upright position. o Do not insert any foreign objects into the valve outlet. You may damage the back-check. Adamaged back-check can be the source of aleak. Leaking propane may result in explosion, fire, severe personal injury or death. o Never fill the cylinder beyond 80% full. o o IF THE ABOVE INSTRUCTIONS ARE NOT FOLLOWED EXACTLY, A FIRE CAUSING DEATH OR SERIOUS INJURY MAY OCCUR. DO NOT CONNECT TO APROPANE GAS CYLINDER EXCEEDING THIS CAPACITY, OR USE ACYLINDER WITH ANY OTHER TYPE OF VALVE 4 PARTS LIST ITEM 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 56a 56b 56c 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 n 78 79 80 81 82 83 84 85 86 87 88 89 90 QTY. 1 1 1 1 1 2 1 2 8 2 1 2 2 1 1 1 1 1 2 1 1 1 2 6 6 1 1 1 1 3 1 2 8 10 4 4 1 1 1 1 1 1 2 4 12 12 1 4 2 2 4 8 8 8 8 1 1 1 1 1 1 1 1 2 2 11 1 1 4 2 1 1 12 1 1 4 4 8 1 1 4 4 2 1 1 1 4 1 4 4 SP PART No. SP30-1X :;1"'37-33 X SP38-33X SP336-9 SP251-9 SP43-33 SP69-19 SP54·21 SP40-16 :;P8-25 SP57·30 SP92·18 SP53-16 SP324-9X SP39·33X SP40-33X SP326·9X SP187·6 SP47·21 :;P321-9 SP20-38 SP95-6 X SP47·21 SP82·18 SP4,.,6 SP69-12 SP51·6 SP99-9 SP40·13 SP18-28 SP52-6 SP55·20 SP47-21 SP44-16 SP83·18 SP53-16 SP192·3 SP316-42X SP41A-33X SP42A·33X SP325-9X SP320-9X SP188-6 SP43-21 SP82·18 SP41-16 SP323·9 SP43-21 SP27·38 SP75·21 SP54-6 X SP83·18 SP53·16 SP85·18 SP53·16 SP257·9 SP27-18 SP10-16 SP52·16 SP37-31 X SP22·38 SP329-9 SP24-14 SP48·29 SP319-9 SP28-38 SP46A-6 SP47A-6 SP42-21 SP32-38 SP281-4 SPl5-7 SPl6-7 SP15·38 SP76·20 SP43-21 SP258-9 SP107·12 SP105-12 SP93·5 SP62·21 SP96·12 SP182-6 SP44·21 SP78·20 SP45-21 SP259-9 SP155-6 SP156·6 SP43·21 SP212·9 SP94A-9 SP199·3 DESCRIPTION COVER ASSEM. COVER AST END t;AI'" LH COVER CAST END CAP RH COVER PANEL COVER LINER COVER PLUG HANDLE 1110·24 X .5 RD HD SS PHILIP SELF·THREAD LOCKNUT 1/4" POST STOP LOGO GAGE ASSEMBLY COVER HINGE SHOULDER BOLT 14-20 N . HEXH[ BASE BACK PANEL 2 ZONE rotisllite ASSEM. CAST END CAP LH CAST END APRH PANELtjAl,,;1\ UPPER DIVIDER BKT 118·32X.375 SS PAN HD SCREW CAST UPPER GRILL DIV DER 2007 LIGHT ASSEM. LIGHT RAIN \:iUAHD 118·32X.375 SS PAN HD SCREW 1110-24.43 CARRIAGE BOLT 1110·24 NUT HEx HU ROTIS BURNER ASSEM. ROTIS VENTURI BRACKET ROTIS PLENUM ROTIS VEN' URI ROTIS BURNER ROTtS BRACKET IGNITER #8-32 X 3/8" PAN Hl PHILIP #8-32 ACORN Nut 114"-20X.50" CARRIAGE BOLT 114-20 NUT HEX HD FLANGED WARMING RACK PORC 240 SO" 650 GRILL IQ 6-VALVE BASE ASSEM. BASE CAST END CAP LH BASE CAST END CAP RH BASE BACK PANEL BASE FRONT PANEL LOWER DIVIDER BKT IIl0X3I8 SCREW SELF TAP B 1110-24.43 CARRIAGE BOLT 1110-24 NUT HEX HD FLANGED LOWER DIVIDER PANEL IIl0X3I8 SCREW SELF TAP B TEMP PROBE SENSOR Pl00-l0l 1/4 ·B X.500" AD HD PHILIP DR BASE SHELF BRACKETS @.275 1/4"-20X.50" CARRIAGE BOLT 1/4-20 NUT HEX HD FLANGED 3/8"SHOLDER BOLT 114-20 114-20 NUT HEX HD FLANGED HEAT BAFFLE 118·32 X .63" RD HD PHILLIP 118·32 HEX NUT #8·32 WING NUT CONSOLE IQ 6 VALVE CONTROLLER ASSEM. CONTROLLER ENCLOSURE CONTROLLER GASKET CONTROLLER GLASS CONTROLLER FACE PANEL EXTERNAL MEAT PROBE BEZEL MAIN BEZEL SIDE/ROnS #8-32'.5/16" RD HD SCREW ELECTRICAL HARNESS VHR 10 6-VALVE 79000 BTU KNOB MAIN KNOB SIDE/ROTIS TOGGLE SWITCH IGNITER ELECTRONIC 6-POLE #10X3I8 SCREW SELF TAP B CONSOLE BAFFLE BURNER ASSEMBLY BURNER CIW AIR SHUTIER @.504 AIRSHUTIER #8 B X 1/4" PAN HD SCREW BURNER CROSS IGNITER MANUAL CROSS OVER BRACE #10 -24 X.375" HEX HD FLANGED SCREW IGNITER MAIN BURNER #10 X 1" HEX HD B SCREW BASE BOTIOM GREASE PAN A CART GREASE RAIL RH A CART GREASE RAIL LH A CART #10·B X 3/8" PAN HD PHILIP GREASE TRAY A CART SMART BAR CAST IRON COOK GRATE Gas Barbeque Grill: Model FGQ65079 SERIES HOW TO ORDER SPARE PARTS: When ordering, always give the following information: 1. The Part Number 2. The Model Description 3. The Serial Number 4. The Part Description 5. Part Color. B = Black, C = Charcoal, BL = Blue, E = Metalic Silver NOTE: THE USE OF NON-MANUFACTURERS REPLACEMENT PARTS AUTOMATICALLY VOIDS THE BARBEQUE WARRANTY. (X = COLOR, BL=BLUE, C=CHARCOAL, B=BLACK, E=METALIC SILVER) 38 ITEM QTY. 91 92 93 94 95 96 97 98 99 100 101 102 103 104 lOS 106 107 108 109 110 111 112 113 114 115 116 117 118 119 120 121 122 123 124 12S 126 127 128 129 130 131 132 133 134 135 136 137 138 139 140 141 142 143 144 145 146 147 148 149 150 151 152 153 154 155 156 lS7 lS8 159 160 161 162 163 164 165 166 167 168 169a 169a 169b 169b 170 171 172 173 174 175 176 177 178 179 180 1 1 2 1 1 1 2 1 1 1 2 1 1 4 2 2 4 1 1 1 4 2 2 4 1 15 4 4 4 4 1 1 1 1 1 1 1 1 1 1 2 1 13 9 11 4 1 1 1 1 4 1 4 4 1 2 1 5 1 1 6 1 4 4 1 2 1 1 1 1 8 1 1 1 2 2 2 2 2 1 1 1 2 8 1 2 1 1 1 SP PART No. SP284-9X SP261-9X SP65-16 SP262-9 SP264-9 SPS7-6X SP46-21 S1"285-9X SP286-9 X SP56-6 X SP46-21 SPl68-6 SP169-6 SP65-16 SP170-6 SP71·21 SP63-21 SP171-6 SP172-6 :;P173-6 SP6S·16 :;P170-6 SP71-21 SP63·21 SP266-9 SP46-16 SPS9-16 SP28-22 :;Pl07-18 SPS3·16 SP328-9 :;P25-38 SP63-33 SP65-33 SP3-27 SP64-33 SP24-38 SP327·9 SP29-1 SP26-38 SP23-38 SP43-21 SP161-6 SP53-16 SP63-18 SP84-18 SP86·18 SP46·21 SP341-9 X SP342-9X SP271-9 SPS7-21 SP343-9X SP66-16 SP71-21 SPS4A·19 SP41·16 SP309-9 SP61·21 SP339-9X SP340·9X SP57·21 SP291·9 SP67·16 SP71·21 SP54A-19 SP41-16 SP337-9X SP338-9X SP164-6 SP41-1S SP47-21 SP17-32 SP20-32 SP54A-19 SP41-16 SP31-22 SP29·22 SP32·22 SP30-22 SP317-42X SP166-9X SP48·6X SP49-6X SP4S·16 SP49·21 SP53·6 SP43-21 SP13·1X SP176A-3 SP55-19 DESCRIPTION AB BACK PANEL CAB PANEL FRONT A CART NR SERIES NUT INSERT PANEL RH ASSEMBL Y PANEL SIDE RH CART BRACKET RH 1/4"Xl/2"SCREW HEX HD SELF TAP B PANEL LH AssEMBLY PANEL SIDE LH CART BRA KET LH 1I4''X1/2''SCREW HEX HD SELF TAP B DRAWt:R RAIL BKT LH ASSt:MBLY DRAWER RAIL BKT LH Itl0-24NR SERIE~ NUT INSERT DRAWER SLIDE #8-32 X S/16" FLK· He PHILLP Itl 0--24 X .S" RD HO PHILLIP FRONT BRA KET DRAWER RAIL BKT RH ASSEMBLY DRAWER RAIL SKT RH Itl0-24NR SERIES NUT INSERT DRAWER SLIDE 1t8-32 X S/16" FLAT HD PHILLP Itl0--24 X .S" RD HD PHILLIP BonOM PAN RESIN 1/4-20 INSERT NUT 318-16 INSERT NUT TANK DRAWER WHEELS 318"X.38· SHOULDER BOLT 1/4-20 NUT HEX HD FLANGED TANK CADDY IQ TANK SENSOR GAl:it: A:;:;EMBLY TANK SENSOR PLUNGER URITHANE DISC CAP TANK SENOR SPRING TANK SENSOR BELLOWS TANK AMPLIFIER ASSEMBLY AMPLIFIER BOARD BOX AMPLIFIER BOARD COVER AMPLIFIER BOARD TANK SENSOR Itl0X3I8 SCREW SELF TAP B TANK CADDY LOCK 1/4-20 NUT HEX HD FLANGED 1/4"-20X.SO" CARRIAGE BOLT 1/4-20 X .5 HEX HD BOLT 1/4"-20 X .75" CARRIAGE BOLT 1/4"Xl/2" HEX HD SELF TAP B DRAWER UPPER ASSY FRONT DRAWER PANEL FRONT PANEL LINER Itl0 X .5" RD HD SCREW DRAWER UPPER Gas Barbeque Grill: Model FGQ65079 SERIES HOW TO ORDER SPARE PARTS: When ordering, always give the following information: 1. The Part Number 2. The Model Description 3. The Serial Number 4. The Part Description 5. Part Color, B = Black, C = Charcoal, BL= Blue, E = Metalic Silver NOTE: THE USE OF NON-MANUFACTURERS REPLACEMENT PARTS AUTOMATICALLY VOIDS THE BARBEQUE WARRANTY. 1t8-32 NR SERIES NUT INSERT #8-32 X 5716" FLAT HD PHILLP HANDLE CHROME PLATE Itl0-24 FLANGED HEX NUT LOWER HEAT SHIELD Itlo-B X 3/8" RD HD PHILLIp DRAWER LOWER ASSY FRONT DRAWER PANEL Itl0 X .5" RD HD SCREW B DRAWER LOWER 118-32 BARB-INSERT 118-32 X 5/16" FLAT HD PHILLP HANDLE CHROME pLATE #10-24 FLANGED HEX NUT DOOR RHASSY DOOR RH PANEL DOOR INSIDE RH MAGNET 1t8-32 X 3/8" PAN HD PHILIP HINGE PIN LOWER HINGE PIN TOP HANDLE CHROME pLATE 1t10-24 FLANGED HEX NUT INDUSTRIAL CASTER 3" - NON LOCKING (BLACK FINISH) INDUSTRIAL CASTER 3" - NON LOCKING (SILVER FINISH) INDUSTRIAL CASTER 3" .. LOCKING (BLACK FINISH) INDUSTRIAL CASTER 3" • LOCKING (SILVER FINISH) RESIN SIDE SHELF ASSEMBLY RESIN SIDE SHELF LH SHELF BRACKET LH SHELF BRACKET RH 1/4-20 HEX HEAD WELD NUT #10"X.75" HEX FLANGE HD SELF TAP B SHELF TRIM LH #10X3/8 SCREW SELF TAP SHELF COVER HINGE WIRE TOWEL BAR (X = COLOR, BL=BLUE, C=CHARCOAL, B=BLACK, E=METALIC SILVER) 39 ITEM 181 182 183 184 185 186 187 188 189 190 191 192 193 194 195 196 197 198 199 200 201 202 203 204 205 206 207a 207b 208 209 210 211 212 213 214 215 216 217 218 219 220 221 QTY. 1 2 2 1 1 6 1 1 1 1 1 1 1 1 1 1 1 1 1 8 1 1 1 1 1 2 1 1 2 1 1 1 2 1 1 1 1 1 1 1 1 SP PART No. SP83-6 SP57-21 SP87-18 SP261-42 SP12-2 SP55-6 SP43-21 SP167-9 SP12-1 SP176A-3 SP60-16 SP262-42 SP48-6 SP97-6 SP45-16 SP263-42 SP49-6 SP98-6 SP45-16 SP55-19 SP49-21 SP70A-12 SP71-12 SP72A-12 SP41-13 SP56-20 SP42-21 SP64-21 SP165-3 SP87-18 SP50-6 SP7-1 SP5-2 SP48-21 SP17-38 SP29-38 SPll0A-9 SPlllA-9 SP56-45 SP186-42 SP195-3 SP36-38 DESCRIPTION TOOL HOOK LH #10 X .5" RD HD SCREW B 1/4 20X.5 WING BOLT RESIN SIDE BURNER ASSEMBLY SIDE BURNER RESIN BASE SHELF TRIM RH #10X3/8 SCREW SELF TAP B SIDE BURNER PAN SHELF COVER HINGE WIRE SPEED NUT PUSH ON RESIN SIDE BURNER BACK BKT ASSEMBLY SHELF BRACKET LH SBURNER BACK BKT 1/4-20 HEX HEAD WELD NUT RESIN SIDE BURNER FRONT BKT ASSEMBLY SHELF BRACKET RH SBURNER FRONT BKT 1 4-20 HEX HEAD WELD NUT TOWEL BAR #10"X.75" HEX FLANGE HD SELF TAP B SIDE BURNER ASSEMBLY CAST BRONZE COVER CAST IRON BASE VENTURI IGNITER #8-32-.5/16" RD HD SCREW #8-32-.5116" RD HD SCREW CAST IRON GRATE 1/4 20X.5 WING BOLT BOTTLE OPENER SMOKER COVER SMOKER BASE #12 X.500 L-SCREW @.014 RESIN 2-0UTLET 111NLET BOX TRANSFORMER CLASS B WINE BUCKET CONDIMENT CONDIMENT TRAY BATTERY AA ROTIS KIT (OPTIONALl ROTIS ROD (OPTIONALl EXTERNAL MEAT HARNESS Gas Barbeque Grill: Model FGQ65079 SERIES HOW TO ORDER SPARE PARTS: When ordering, always give the following information: 1. The Part Number 2. The Model Description 3. The Serial Number 4. The Part Description 5. Part Color, B = Black, C = Charcoal, BL= Blue, E = Metalic Silver NOTE: THE USE OF NON-MANUFACTURERS REPLACEMENT PARTS AUTOMATICALLY VOIDS THE BARBEQUE WARRANTY. (X = COLOR, BL=BLUE, C=CHARCOAL, B=BLACK, E=METALIC SILVER) 40