Download universal cooling system pressure test kit
Transcript
UNIVERSAL COOLING SYSTEM PRESSURE TEST KIT ■ STOCK No. 54715. ■ PART No. COOL/KIT. • INSTRUCTIONS • IMPORTANT: PLEASE READ THESE INSTRUCTIONS CAREFULLY TO ENSURE THE SAFE AND EFFECTIVE USE OF THIS TOOL. 12/97 OPERATING INSTRUCTIONS WARNING: Before removing the vehicles Cooling System Cap be aware the system may be pressurised with very hot coolant. Remove cap carefully. The Draper Cooling System Tester is supplied in a secure carry case containing; a Pump, Hose, and Universal Adaptor. Individual adaptors are available separately for certain bayonet or screw fitting caps. Where the universal adaptor is not suitable. To pressurise the cooling system adjust and insert the adaptor to give a ‘snug’ fit in the expansion tank or radiator opening, then twist the upper hand wheel clockwise to expand the rubber bung (see diagram). OPERATING INSTRUCTIONS cont’d Connect the hand pump and hose to the adaptor via the brass quick release adaptor. Using the hand pump, pressurise the system to the manufacturers recommended pressure, refer to manufacturers service manual for pressure, or it may be found on the vehicles cap. The gauge should hold pressure, indicating that no leakage is occurring in the vehicles cooling system. If the pressure reading drops it can indicate leakage which can occur in hoses, joints, head gasket and other areas such as water pump seals, radiator etc. When removing the tester, slacken the adaptor hand wheel carefully, allowing the pressure to reduce slowly. REMEMBER: Very hot water maybe present so exercise care when de-pressurising and it is recommended for detailed and concise instructions on the correct use of this tool refer to the vehicle manufacturer’s service manual. OPTIONAL ACCESSORIES SMALL BAYONET ADAPTOR K33 TYPE SUITABLE FOR JAPANESE/ASIAN CARS/LIGHT COMMERCIAL VEHICLES. PART No. ACOOL/K33 STOCK No.54853. STANDARD BAYONET ADAPTOR K60 TYPE PART No. ACOOL/K60. STOCK No.54854. DRAPER TOOLS LIMITED, Hursley Road, Chandler's Ford, Eastleigh, Hants. SO53 1YF. England. Tel: (01703) 266355. Fax: (01703) 260784. YOUR DRAPER STOCKIST ©Published by Draper Tools Ltd. No part of this publication may be reproduced, stored in a retrieval system or transmitted in any form or by any means, electronic, mechanical photocopying, recording or otherwise without prior permission in writing from Draper Tools Ltd.