Download Nokia_Asha 230 RM-986_987 Service manual L1L2 - Nokia-X
Transcript
Service Manual for L1 and L2 Nokia Asha 230 Nokia Asha 230 Dual SIM RM-986(DS), RM-987(SS) Key features Send feedback 2.8" display with 320 x 240 resolution 1.3 Mpix camera Quick photo sharing Dual SIM support (RM-986 only) Micro SD card support up to 32 GB Recommend Change in KICS Rate this page in KICS E-mail [email protected] Version 1.0 Exploded view CHECK THE REPAIR POLICY BEFORE PERFORMING ANY MECHANICAL REPAIR ON SERVICE LEVEL 1&2! Disassembly steps More Assembly hints Solder components More More Service devices More Product controls and interfaces More Service concept More ©2014 Nokia | Nokia Internal Use only | All Rights Reserved. More Service Manual Level 1 and 2 Nokia Asha 230, Nokia Asha 230 Dual SIM RM-986(DS), RM-987(SS) Version 1.0 Version history Version Date Description 1.0 27.02.2014 First published version ©2014 Nokia | Nokia Internal Use only | All Rights Reserved. Service Manual Level 1 and 2 Nokia Asha 230, Nokia Asha 230 Dual SIM RM-986(DS), RM-987(SS) Version 1.0 1 Exploded view A-COVER ASSEMBLY (I0001 - I0004) TOUCH PANEL I0002 A-COVER I0001 EARPIECE ADHESIVE I0003 EARPIECE I0004 DISPLAY I0005 LIGHT SWAP PACKAGE RF SHIELDING LID I0009 (I0006 - I0011) LIGHT SWAP PWB I0007 DISPLAY CONDUCTIVE TAPE I0010 BB SHIELDING LID I0008 TYPE LABEL I0011 TOUCH IC GASKET I0006 CAMERA I0012 3 2 SPEAKER I0017 D-COVER ASSEMBLY (I0013 - I0016) D-COVER I0016 SIM LID I0015 SPEAKER MESH WITH GASKET I0013 BT ANTENNA I0014 SCREW TORX+ SIZE 6 RF1.6 x 4.5 I0019 MAIN ANTENNA I0018 BATTERY COVER I0020 Only available as assembly ©2014 Nokia | Nokia Internal Use only | All Rights Reserved. Not reuseable after removal Repair/swap only in level 3 Service Manual Level 1 and 2 Nokia Asha 230, Nokia Asha 230 Dual SIM RM-986(DS), RM-987(SS) Version 1.0 Disassembly steps 1) For disassembling you need the Nokia Standard toolkit version 2. You will also need the camera removal tool SS-276. 2) Protect the TOUCH PANEL with protective film. ©2014 Nokia | Nokia Internal Use only | All Rights Reserved. 3) Pull from the shown corners and push from the middle of the BATTERY COVER to release it. Remove the BATTERY COVER. 4) Unscrew the four Torx+ size 6 screws in the order shown. ©2014 Nokia | Nokia Internal Use only | All Rights Reserved. 5) Insert the SRT-6 to shown corner to release the shown clip holding the D-COVER. 6) Use the SRT-6 to release the two shown clips. ©2014 Nokia | Nokia Internal Use only | All Rights Reserved. 7) Release also the clip on the bottom end of the device. 8) Release the two shown clips on the right side of the device. ©2014 Nokia | Nokia Internal Use only | All Rights Reserved. 9) The D-COVER can now be released. 10) Push from the shown place with the sharp end of the SS-93 to release the MAIN ANTENNA. ©2014 Nokia | Nokia Internal Use only | All Rights Reserved. 11) Push the SS-93 under the MAIN ANTENNA to release it. Remove the MAIN ANTENNA. 12) Clean the MAIN ANTENNA adhesive remains from the D-COVER. Do not use them again. ©2014 Nokia | Nokia Internal Use only | All Rights Reserved. 13) Release the SPEAKER with the dental tool. Be careful not to injure yourself with the sharp end of the dental tool. 14) Release the SPEAKER MESH WITH GASKET with the dental tool. Remove it with tweezers. Discard it. ©2014 Nokia | Nokia Internal Use only | All Rights Reserved. 15) Open the DISPLAY connector with the SS-93. Be careful not to damage the connector or any nearby components. 16) To remove the A-COVER release the shown clip with the SS-93. ©2014 Nokia | Nokia Internal Use only | All Rights Reserved. 17) Release also the second clip holding the A-COVER. 18) The A-COVER can now be separated. ©2014 Nokia | Nokia Internal Use only | All Rights Reserved. 19) Protect the other side of the TOUCH PANEL with protective film. 20) Protect the DISPLAY with protective film. ©2014 Nokia | Nokia Internal Use only | All Rights Reserved. 21) Release the EARPIECE with the dental tool. Remove it with tweezers. Do not use the EARPIECE again. Discard it. 22) Remove and discard the EARPIECE ADHESIVE. ©2014 Nokia | Nokia Internal Use only | All Rights Reserved. 23) Push the SS-93 under the DISPLAY from shown side. Slowly push the SS-93 towards the bottom end release the DISPLAY. Be careful not to damage the DISPLAY. 24) Remove the DISPLAY. ©2014 Nokia | Nokia Internal Use only | All Rights Reserved. 25) Use the SS-93 to release the two DISPLAY CONDUCTIVE TAPES. Remove them with tweezers. Do not use them again. Discard them. 26) Use the dental tool to lift up the TOUCH IC GASKET. Remove and discard it. ©2014 Nokia | Nokia Internal Use only | All Rights Reserved. 27) Use the camera removal tool SS-276 to remove the CAMERA. Note the alignment of the tool. Place the SS-276 on top of the CAMERA and push it down. Then press and hold the button on the SS-276 to lock it to the CAMERA. 28) Lift up the SS-276 and remove the CAMERA. ©2014 Nokia | Nokia Internal Use only | All Rights Reserved. 29) Use the SS-93 to peel off the TYPE LABEL. Remove and discard the TYPE LABEL. 30) Nokia Asha 230 / Nokia Asha 230 Dual SIM disassembly procedure is complete. -END OF DISASSEMBLY- ©2014 Nokia | Nokia Internal Use only | All Rights Reserved. Service Manual Level 1 and 2 Nokia Asha 230, Nokia Asha 230 Dual SIM RM-986(DS), RM-987(SS) Version 1.0 Assembly hints Fasten the four shown Torx+ size 6 screws to the torque of 14Ncm. ©2014 Nokia | Nokia Internal Use only | All Rights Reserved. Service Manual Level 1 and 2 Solder components Nokia Asha 230, Nokia Asha 230 Dual SIM RM-986(DS), RM-987(SS) Version 1.0 TOP Grounding spring Grounding spring X7452 V X7451 X1002 X7453 X7450 Touch panel connector Grounding spring Grounding spring BOTTOM USB EMI filter USB transistor 2nd SIM ASIP USB transistor MicroSD ASIP Display transistor Battery transistor Z3301 V2201 R2751 V2221 R3200 V1025 V2207 Battery transistor USB fuse F3300 V6100 Grounding Spring Vol/Zoom+ switch R2750 S1001 S1002 J7401 SIM ASIP Vol/Zoomswitch Lock/Power switch Antenna spring ©2014 Nokia | Nokia Internal Use only | All Rights Reserved. J7400 Antenna spring Antenna spring Service Manual Level 1 and 2 Nokia Asha 230, Nokia Asha 230 Dual SIM RM-986(DS), RM-987(SS) Version 1.0 CA-101 Service cable Service devices AC-18 (Global) AC-20B (Brazil) AC-19C + CA-190CD (China) AC-21W + CA-190CD (Taiwan) Nokia Standard Toolkit (v2) For more information, refer to the Service Bulletin (SB-011) on Nokia Online. Supplier or manufacturer contacts for tool re-order can be found in “Recommended service equipment” document on Nokia Online. ©2014 Nokia | Nokia Internal Use only | All Rights Reserved. SS-276 Camera removal tool Service Manual Level 1 and 2 Nokia Asha 230, Nokia Asha 230 Dual SIM RM-986(DS), RM-987(SS) Version 1.0 Product controls and interfaces 2 1 1 — Micro-USB connector 2 — 3.5 mm AHJ connector 3 — Earpiece 4 — Touch screen 3 5 — Back key 6 — Microphone 7 — Camera 8 — Volume/Zoom keys 9 — Lock/Power key 4 10 — Loudspeaker 11 — Antenna area 5 6 7 8 9 10 11 ©2014 Nokia | Nokia Internal Use only | All Rights Reserved. Service Manual Level 1 and 2 Nokia Asha 230, Nokia Asha 230 Dual SIM RM-986(DS), RM-987(SS) Version 1.0 Service concept Flashing concept Service software CA-101 Product specific battery Transceiver ©2014 Nokia | Nokia Internal Use only | All Rights Reserved.