Download SERVICE MANUAL

TA-FE600R
SERVICE MANUAL
AEP Model
SPECIFICATIONS
+0
–3
INTEGRATED STEREO AMPLIFIER
MICROFILM
—1—
TABLE OF CONTENTS
1. GENERAL .................................................................... 3
2. ELECTRICAL ADJUSTMENT ....................................... 4
3. DIAGRAMS
3-1. Circuit Boards Location ....................................................... 5
3-2. IC Pin Function
• IC902 Input Control LED Driver
(TMP47C103N-JP47) ....................................................... 6
3-3. Schematic Diagram — Panel Section — .............................. 7
3-4. Printed Wiring Board — Panel Section — ........................... 9
3-5. Schematic Diagram — Main Section — ............................ 12
3-6. Printed Wiring Board — Main Section — ......................... 15
4. EXPLODED VIEWS
4-1. Front Panel Section ............................................................ 19
4-2. Chassis Section ................................................................... 20
5. ELECTRICAL PARTS LIST ..................................... 21
SAFETY-RELATED COMPONENT WARNING !!
COMPONENTS IDENTIFIED BY MARK ! OR DOTTED LINE
WITH MARK ! ON THE SCHEMATIC DIAGRAMS AND IN
THE PARTS LIST ARE CRITICAL TO SAFE OPERATION.
REPLACE THESE COMPONENTS WITH SONY PARTS
WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS
MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY.
—2—
SECTION 1
GENERAL
This section is extracted from
instruction manual.
LOCATION OF PARTS AND CONTROLS
FRONT PANEL
1
!¶ !§ !∞
1
2
3
4
5
6
7
8
9
2
!¢
!£
!™ !¡ 0 9
3
87 6 5 4
0 TAPE 1 MONITOR indicator
!¡ TAPE 1 MONITOR switch
!™ LOUDNESS switch
!£ BALANCE control
!¢ TONE (BASS, TREBLE) control
!∞ SPEAKERS selector
!§ Remote control sensor
!¶ PHONES jack
POWER switch
INPUT SELECTOR indicator
SUBSONIC switch
EON LINK switch
EON LINK indicator
VOLUME control
SOURCE DIRECT indicator
SOURCE DIRECT switch
INPUT SELECTOR control
REAR PANEL
1 2
3 4 5 6 7
—3—
9
0
!¡ !™
SECTION 2
ELECTRICAL ADJUSTMENT
Bias Adjustment
1. Rotate fully the bias adjusting semi-fixed resistors (RV301, RV351)
to the MIN position (counterclockwise).
2. Connect a digital voltmeter to the CN406 and CN407.
1 pin
3 pin
CN406
–
+
CN407
+
–
3. Set the slide regulator to 0V, and press the POWER button (ON)
on the set.
4. Raise gradually the slide regulator voltage up to the rated voltage (230 V).
5. At this time, confirm that the SP relay is turned on (it will click).
6. Adjust the RV301 and RV351 so that a reading of digital voltmeter
is 10 mV to 15 mV.
7. Return the slidack to 0 V, and press the POWER button (OFF) on
the set.
Adjustment Location :
Test Point Location :
[MAIN A BOARD] — COMPONENT SIDE —
[MAIN B BOARD] — COMPONENT SIDE —
CN406
1
‘
RV301
3
BIAS
Adjustment
C409
C459
RV351
‘
CN407
C322
3
C372
+
–
DIGITAL
VOLTMETER
—4—
1
+
–
DIGITAL
VOLTMETER
SECTION 3
DIAGRAMS
3-1. CIRCUIT BOARDS LOCATION
MAIN B board
OUTLET board
TRANS board
INPUT board
PANEL board
LED board
MAIN A board
SP TM board
PRO IND board
HP board
SP SW board
VOL board
EON board
—5—
3-2. IC PIN FUNCTION
• IC902 Input Control LED Drive (TMP47C103N-JP47)
Pin No.
Pin Name
Function
I/O
1
X OUT
O
2
X IN
I
3
RESET
I
Reset input.
4
PMD
I
Mode select input.
5
VOL +
O
Motor drive output (+).
6
VOL –
O
Motor drive output (–).
7
SW 0
I
Rotary switch input (CD).
8
SW 1
I
Rotary switch input (TUNER).
System clock. (4MHz)
9
SW 2
I
Rotary switch input (PHONO).
10
EON
I
EON signal input.
11
PHONO
O
PHONO LED drive output.
12
TUNER
O
TUNER LED drive output.
13
CD
O
CD LED drive output.
14
GND
—
Ground.
15
AUX
O
AUX LED drive output.
16
DAT
O
TAPE “2” LED drive output.
17
TAPE
O
TAPE “1” LED drive output.
18
MON
O
MONITOR output.
19
PRY
O
Power relay output.
20
PKY
I
Power key input.
21
MON
I
MONITOR input.
22
SIRCS
I
SIRCS input.
23
MUTE
O
Muting output.
24
SCE
O
Chip enble output.
25
SDT
O
Serial data output.
26
SCK
O
Serial clock output.
27
STOP
I
STOP input.
28
+3V
—
+3V Power supply.
—6—
SECTION 4
EXPLODED VIEWS
NOTE:
• Hardware (# mark) list and accessories and packing materials are given in the last of this parts list.
• Abbreviation
G
: German model
• -XX, -X mean standardized parts, so they may have
some difference from the original one.
• Items marked “*” are not stocked since they are
seldom required for routine service. Some delay
should be anticipated when ordering these items.
• The mechanical parts with no reference number in
the exploded views are not supplied.
The components identified by mark !
or dotted line with mark ! are critical
for safety.
Replace only with part number specified.
4-1. FRONT PANEL SECTION
20
20
not supplied
23
S1
21
24
23
Supplied with J701
18
22
15
19
23
not supplied
24
17
14
13
16
12
23
not supplied
20
24
4
8
10
23
22
4
7
10
11
9
4
6
Supplied with
RV200, RV201,
5
RV203
not supplied
2
3
1
22
22
2
Supplied with RV203
Supplied with
S901
Ref. No.
Part No.
Description
1
2
3
4
5
X-4946-920-1
X-4947-025-1
4-980-766-21
4-980-775-01
4-980-771-01
KNOB (VOL) ASSY
FOOT ASSY
PANEL, FRONT
LENS, LED
KNOB (DIA. 47) (SELECTOR)
6
7
8
9
10
4-980-204-01
4-965-651-01
4-979-587-01
X-4946-923-1
4-980-773-01
KNOB (DIA. 24) (TONE)
EMBLEM (MOS)
EMBLEM, SONY
PANEL ASSY, BASE
BUTTON (DIA. 6) (EON)
* 11
12
* 13
1-660-566-11 EON BOARD
4-980-776-01 WINDOW, REMOTE CONTROL
1-662-376-11 HP BOARD
22
Remark
Ref. No.
Part No.
Description
Remark
* 14
* 15
1-660-562-11 LED BOARD
A-4389-795-A PANEL BOARD, COMPLETE
* 16
* 17
18
* 19
20
1-660-565-11
1-660-564-11
4-980-199-01
1-660-567-11
3-704-366-01
VOL BOARD
SP SW BOARD
BUTTON (POWER)
PRO IND BOARD
SCREW (CASE) (M3X8)
21
22
23
24
! S1
4-979-945-41
4-967-961-01
4-951-620-01
7-682-548-04
1-554-920-11
CASE (412032)
SCREW (3X8)
SCREW (2.6X8), +BVTP
SCREW +BVTT 3X8 (S)
SWITCH, PUSH (AC POWER)(1 KEY)(POWER)
— 19 —
4-2. CHASSIS SECTION
51
F801
60
51
not supplied
CNP801
Q454
57
F802
51
Q403
60
63
52
52
61
CNJ802
Q406B
CNJ801
Q453
62
CNJ803
59
58
60
51
57
51
Q404
51
not supplied
64
55
T1
51
not supplied
56
not supplied
54
51
not supplied
53
51
The components identified by mark !
or dotted line with mark ! are critical
for safety.
Replace only with part number specified.
Ref. No.
Part No.
Description
51
52
* 53
* 54
* 55
4-967-961-01
4-967-960-01
A-4389-792-A
1-660-563-11
1-660-573-11
SCREW (3X8)
SCREW (4X8)
MAIN A BOARD, COMPLETE
INPUT BOARD
OUTLET BOARD
* 56
57
* 58
59
60
4-980-768-21
3-905-609-11
A-4389-793-A
4-947-010-01
4-981-016-01
PANEL, BACK
SCREW (TRANSISTOR)
MAIN B BOARD, COMPLETE
SCREW, FEEDER FIXED
SCREW (H)
* 61
* 62
* 63
64
3-703-244-00
1-660-571-11
1-660-574-11
3-704-515-41
BUSHING (2104), CORD
SP TM BOARD
TRANS BOARD
SCREW (BV/RING)
Remark
Ref. No.
Part No.
Description
Remark
! CNJ801 1-526-794-11 OUTLET, AC (AC OUTLET SWITCHED 100W MAX)
! CNJ802
! CNJ803
! CNP801
! F801
! F802
1-526-794-11
1-526-794-11
1-777-185-11
1-532-388-51
1-532-464-51
OUTLET, AC (AC OUTLET SWITCHED 100W MAX)
OUTLET, AC (AC OUTLET SWITCHED 100W MAX)
CORD, POWER
FUSE, TIME LAG (2.0A 250V)
FUSE, TIME LAG (2.5A 250V)
Q403
Q404
Q453
Q454
Q406B
8-729-232-45
8-729-232-46
8-729-232-45
8-729-232-46
8-729-209-15
TRANSISTOR 2SK1529-Y
TRANSISTOR 2SJ200-Y
TRANSISTOR 2SK1529-Y
TRANSISTOR 2SJ200-Y
TRANSISTOR 2SD2012
! T1
— 20 —
1-429-492-11 TRANSFORMER, POWER
SECTION 5
ELECTRICAL PARTS LIST
EON
HP
INPUT
Note:
The components identified by mark !
or dotted line with mark ! are critical
for safety.
Replace only with part number specified.
When indicating parts by reference
number, please include the board
name.
Ref. No.
Part No.
• Due to standardization, replacements in the parts list
may be different from the parts specified in the diagrams or the components used on the set.
• -XX, -X mean standardized parts, so they may have
some difference from the original one.
• Items marked “*” are not stocked since they are seldom required for routine service. Some delay should
be anticipated when ordering these items.
• RESISTORS
All resistors are in ohms
METAL: Metal-film resistor
METAL OXIDE: Metal Oxide-film resistor
F : nonflammable
Description
Remark
Ref. No.
• SEMICONDUCTORS
In each case, u: µ , for example:
uA...: µ A..., uPA...: µ PA..., uPB...: µ PB...,
uPC...: µ PC..., uPD...: µ PD...
• CAPACITORS
uF : µ F
• COILS
uH : µ H
• Abbreviation
G
: German model
Part No.
Remark
< IC >
1-660-566-11 EON BOARD
**********
*
Description
IC101
8-759-805-13 IC LC7821
< CONNECTOR >
< JACK >
CN952
1-691-766-11 PLUG (MICRO CONNECTOR) 4P
*
*
*
*
< DIODE >
D901
8-719-313-72 DIODE SEL3810A-CD (EON LINK)
J101
J102
J103
J104
1-573-142-11
1-573-142-21
1-573-142-21
1-573-142-21
< TRANSISTOR >
< RESISTOR >
R901
1-249-397-11 CARBON
22
5%
1/4W
< SWITCH >
S902
Q924
Q925
Q926
8-729-620-05 TRANSISTOR 2SC2603-EF
8-729-620-05 TRANSISTOR 2SC2603-EF
8-729-620-05 TRANSISTOR 2SC2603-EF
< RESISTOR >
1-571-112-21 SWITCH, PUSH (1 KEY) (EON LINK)
**************************************************************
1-662-376-11 HP BOARD
*********
*
JACK, PIN 4P (INPUT TUNER,PHONO)
JACK, PIN 4P (INPUT AUX,CD)
JACK, PIN 4P (TAPE 1/DAT REC OUT,IN)
JACK, PIN 4P (TAPE 2/MD REC OUT,IN)
R101
R102
R103
R104
R105
1-249-995-11
1-249-995-11
1-249-995-11
1-247-713-11
1-249-995-11
CARBON
CARBON
CARBON
CARBON
CARBON
1M
1M
1M
1K
1M
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R106
R107
R110
R111
R151
1-247-713-11
1-249-995-11
1-249-995-11
1-249-995-11
1-249-995-11
CARBON
CARBON
CARBON
CARBON
CARBON
1K
1M
1M
1M
1M
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R152
R153
R154
R155
R156
1-249-995-11
1-249-995-11
1-247-713-11
1-249-995-11
1-247-713-11
CARBON
CARBON
CARBON
CARBON
CARBON
1M
1M
1K
1M
1K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R157
R160
R161
R945
R946
1-249-995-11
1-249-995-11
1-249-995-11
1-249-429-11
1-249-429-11
CARBON
CARBON
CARBON
CARBON
CARBON
1M
1M
1M
10K
10K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R947
R957
1-249-429-11 CARBON
1-249-425-11 CARBON
10K
4.7K
5%
5%
1/4W
1/4W
< JACK >
J701
1-750-735-11 JACK (LARGE TYPE) (PHONES)
**************************************************************
1-660-563-11 INPUT BOARD
************
*
< CAPACITOR >
C950
C952
C953
C960
1-162-294-31
1-164-159-11
1-164-159-11
1-126-963-11
CERAMIC
CERAMIC
CERAMIC
ELECT
0.001uF
0.1uF
0.1uF
4.7uF
10%
20%
< CONNECTOR >
CN16
CN200
CN904
1-564-320-00 PIN,CONNECTOR (B2P-VH)2P
1-691-766-11 PLUG (MICRO CONNECTOR) 4P
1-691-773-11 PLUG (MICRO CONNECTOR) 11P
50V
50V
50V
50V
< RELAY >
< DIODE >
D950
D951
8-719-987-63 DIODE 1N4148M
8-719-987-63 DIODE 1N4148M
RY101
1-515-614-11 RELAY
**************************************************************
— 21 —
LED
Ref. No.
MAIN A
Part No.
Description
Remark
1-660-562-11 LED BOARD
**********
*
Remark
0.056uF
0.016uF
5%
5%
50V
50V
< DIODE >
C357
C358
C359
C360
C361
1-126-059-11
1-126-022-11
1-126-013-11
1-126-023-11
1-102-973-00
ELECT
ELECT
ELECT
ELECT
CERAMIC
10uF
47uF
1000uF
100uF
100PF
20%
20%
20%
20%
5%
50V
25V
16V
25V
50V
DIODE
DIODE
DIODE
DIODE
DIODE
C362
C363
C365
C366
C367
1-126-059-11
1-164-079-11
1-102-230-00
1-126-023-11
1-126-023-11
ELECT
CERAMIC
CERAMIC
ELECT
ELECT
10uF
330PF
4PF
100uF
100uF
20%
10%
0.25PF
20%
20%
50V
50V
500V
16V
16V
C368
C369
C370
C371
C372
1-126-023-11
1-126-023-11
1-110-392-11
1-164-040-11
1-126-056-11
ELECT
ELECT
ELECT
CERAMIC
ELECT
100uF
100uF
47uF
4PF
1000uF
20%
20%
20%
0.25PF
20%
16V
16V
63V
50V
50V
D600
D601
D602
D603
D604
8-719-313-72
8-719-313-72
8-719-313-72
8-719-313-72
8-719-313-72
D605
D606
D607
8-719-313-72 DIODE SEL3810A-CD (TUNER)
8-719-313-72 DIODE SEL3810A-CD (PHONO)
8-719-313-72 DIODE SEL3810A-CD (TAPE 1 MONITOR)
SEL3810A-CD (SOURCE DIRECT)
SEL3810A-CD (TAPE 1/DAT)
SEL3810A-CD (TAPE 2/MD)
SEL3810A-CD (AUX)
SEL3810A-CD (CD)
< RESISTOR >
1-247-751-11 CARBON
1-249-414-11 CARBON
820
560
5%
5%
1/2W
1/4W
< CONNECTOR >
CN301
CN302
< SWITCH >
1-691-769-11 PLUG (MICRO CONNECTOR) 7P
1-691-765-11 PLUG (MICRO CONNECTOR) 3P
1-554-303-21 SWITCH, TACTILE (TAPE 1 MONITOR)
< DIODE >
**************************************************************
A-4389-792-A MAIN A BOARD, COMPLETE
***********************
*
Description
1-136-162-00 FILM
1-137-471-11 FILM
CNJ902 1-766-796-11 CONNECTOR, BOARD TO BOARD 12P
S203
Part No.
C355
C356
< CONNECTOR >
R926
R940
Ref. No.
D301
D302
D303
D304
D305
8-719-310-60
8-719-933-88
8-719-933-41
8-719-987-63
8-719-987-63
DIODE
DIODE
DIODE
DIODE
DIODE
SEL1510C-C
HZS16-2L
HZS6C3L
1N4148M
1N4148M
D306
D307
D308
D309
D351
8-719-310-60
8-719-987-63
8-719-987-63
8-719-987-63
8-719-310-60
DIODE
DIODE
DIODE
DIODE
DIODE
SEL1510C-C
1N4148M
1N4148M
1N4148M
SEL1510C-C
D352
D353
D354
D355
D356
8-719-933-88
8-719-933-41
8-719-987-63
8-719-987-63
8-719-310-60
DIODE
DIODE
DIODE
DIODE
DIODE
HZS16-2L
HZS6C3L
1N4148M
1N4148M
SEL1510C-C
D357
D358
D359
8-719-987-63 DIODE 1N4148M
8-719-987-63 DIODE 1N4148M
8-719-987-63 DIODE 1N4148M
< CAPACITOR >
C301
C302
C304
C305
C306
1-102-978-00
1-126-059-11
1-106-359-00
1-136-162-00
1-137-471-11
CERAMIC
ELECT
MYLAR
FILM
FILM
220PF
10uF
4700PF
0.056uF
0.016uF
5%
20%
5%
5%
5%
50V
50V
200V
50V
50V
C307
C308
C309
C310
C311
1-126-059-11
1-126-022-11
1-126-013-11
1-126-023-11
1-102-973-00
ELECT
ELECT
ELECT
ELECT
CERAMIC
10uF
47uF
1000uF
100uF
100PF
20%
20%
20%
20%
5%
50V
25V
16V
25V
50V
C312
C313
C315
C316
C317
1-126-059-11
1-164-079-11
1-102-230-00
1-126-023-11
1-126-023-11
ELECT
CERAMIC
CERAMIC
ELECT
ELECT
10uF
330PF
4PF
100uF
100uF
20%
10%
0.25PF
20%
20%
50V
50V
500V
16V
16V
C318
C319
C320
C321
C322
1-126-023-11
1-126-023-11
1-110-392-11
1-164-040-11
1-126-056-11
ELECT
ELECT
ELECT
CERAMIC
ELECT
100uF
100uF
47uF
4PF
1000uF
20%
20%
20%
0.25PF
20%
16V
16V
63V
50V
50V
C351
C352
C354
1-102-978-00 CERAMIC
1-126-059-11 ELECT
1-106-359-00 MYLAR
220PF
10uF
4700PF
5%
20%
5%
50V
50V
200V
< IC >
IC301
8-759-636-74 IC M5218AP-22
< COIL >
L301
L351
1-411-925-11 COIL, AIR-CORE
1-411-925-11 COIL, AIR-CORE
< TRANSISTOR >
Q301
— 22 —
8-729-281-54 TRANSISTOR 2SC1815-BL
MAIN A
Ref. No.
Part No.
Description
Remark
Q302
Q303
Q304
Q305
8-729-281-54
8-729-281-54
8-729-620-17
8-729-201-53
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC1815-BL
2SC1815-BL
2SC2259-FG
2SA1015-GR
Q306
Q307
Q308
Q309
Q310
8-729-201-53
8-729-201-53
8-729-021-74
8-729-202-67
8-729-021-73
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SA1015-GR
2SA1015-GR
2SA949-OY-TPE6
2SK246-GR3
2SC2229-OY-TPE6
Q311
Q312
Q351
Q352
Q353
8-729-281-54
8-729-281-54
8-729-281-54
8-729-281-54
8-729-201-53
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC1815-BL
2SC1815-BL
2SC1815-BL
2SC1815-BL
2SA1015-GR
Q354
Q355
Q356
Q357
Q358
8-729-620-17
8-729-201-53
8-729-201-53
8-729-201-53
8-729-021-74
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC2259-FG
2SA1015-GR
2SA1015-GR
2SA1015-GR
2SA949-OY-TPE6
Q359
Q360
Q361
Q362
8-729-202-67
8-729-021-73
8-729-281-54
8-729-281-54
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SK246-GR3
2SC2229-OY-TPE6
2SC1815-BL
2SC1815-BL
< RESISTOR >
R301
R302
R303
R304
R305
1-259-215-21
1-249-911-11
1-259-215-21
1-249-900-11
1-259-161-21
CARBON
CARBON
CARBON
CARBON
CARBON
100K
330
100K
110
560
5%
5%
5%
1%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R306
R307
R308
R309
R310
1-259-161-21
1-259-143-21
1-259-191-21
1-249-844-11
1-249-818-11
CARBON
CARBON
CARBON
CARBON
CARBON
560
100
10K
56K
4.7K
5%
5%
5%
1%
1%
1/4W
1/4W
1/4W
1/2W
1/2W
R311
R313
R314
R315
R316
1-259-167-21
1-249-943-11
1-249-198-11
1-249-198-11
1-249-198-11
CARBON
CARBON
CARBON
CARBON
CARBON
1K
6.8K
330
330
330
5%
5%
5%
5%
5%
1/4W
1/4W
1/3W
1/3W
1/3W
R317
R318
R319
R320
R321
1-249-198-11
1-259-167-21
1-259-151-21
1-259-151-21
1-259-151-21
CARBON
CARBON
CARBON
CARBON
CARBON
330
1K
220
220
220
5%
5%
5%
5%
5%
1/3W
1/4W
1/4W
1/4W
1/4W
R322
R323
R324
R325
R326
1-259-215-21
1-259-179-21
1-249-931-11
1-259-444-11
1-249-490-11
CARBON
CARBON
CARBON
CARBON
CARBON
100K
3.3K
2.2K
4.7K
27K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/6W
1/3W
R327
R328
1-259-151-21 CARBON
1-259-151-21 CARBON
220
220
5%
5%
1/4W
1/4W
Ref. No.
Part No.
Description
Remark
R329
R330
R331
1-249-899-11 CARBON
1-247-749-11 CARBON
1-249-496-11 CARBON
100
560
100K
5%
5%
5%
1/4W
1/2W
1/3W
R332
R333
R334
R335
R351
1-259-171-21
1-259-167-21
1-124-995-11
1-259-143-21
1-259-215-21
CARBON
CARBON
CARBON
CARBON
CARBON
1.5K
1K
1M
100
100K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R352
R353
R354
R355
R356
1-249-911-11
1-259-215-21
1-249-900-11
1-259-161-21
1-259-161-21
CARBON
CARBON
CARBON
CARBON
CARBON
330
100K
110
560
560
5%
5%
1%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R357
R358
R359
R360
R361
1-259-143-21
1-259-191-21
1-249-844-11
1-249-818-11
1-259-167-21
CARBON
CARBON
CARBON
CARBON
CARBON
100
10K
56K
4.7K
1K
5%
5%
1%
1%
5%
1/4W
1/4W
1/2W
1/2W
1/4W
R363
R364
R365
R366
R367
1-249-943-11
1-249-198-11
1-249-198-11
1-249-198-11
1-249-198-11
CARBON
CARBON
CARBON
CARBON
CARBON
6.8K
330
330
330
330
5%
5%
5%
5%
5%
1/4W
1/3W
1/3W
1/3W
1/3W
R368
R369
R370
R371
R372
1-259-167-21
1-259-151-21
1-259-151-21
1-259-151-21
1-259-215-21
CARBON
CARBON
CARBON
CARBON
CARBON
1K
220
220
220
100K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R373
R374
R375
R376
R377
1-259-179-21
1-249-931-11
1-259-444-11
1-249-490-11
1-259-151-21
CARBON
CARBON
CARBON
CARBON
CARBON
3.3K
2.2K
4.7K
27K
220
5%
5%
5%
5%
5%
1/4W
1/4W
1/6W
1/3W
1/4W
R378
R379
R380
R381
R382
1-259-151-21
1-249-899-11
1-247-749-11
1-249-496-11
1-259-171-21
CARBON
CARBON
CARBON
CARBON
CARBON
220
100
560
100K
1.5K
5%
5%
5%
5%
5%
1/4W
1/4W
1/2W
1/3W
1/4W
R383
R384
R385
1-259-167-21 CARBON
1-124-995-11 CARBON
1-259-143-21 CARBON
1K
1M
100
5%
5%
5%
1/4W
1/4W
1/4W
< VARIABLE RESISTOR >
RV301
RV351
1-241-762-11 RES, ADJ, CARBON 2.2K
1-241-762-11 RES, ADJ, CARBON 2.2K
**************************************************************
— 23 —
MAIN B
Ref. No.
Part No.
Description
Remark
Ref. No.
Part No.
A-4389-793-A MAIN B BOARD, COMPLETE
***********************
*
Description
Remark
< TRANSISTOR >
< CAPACITOR >
C401
C402
C404
C405
C406
1-136-163-00
1-136-163-00
1-124-920-11
1-136-163-00
1-126-923-11
FILM
FILM
ELECT
FILM
ELECT
0.068uF
0.068uF
330uF
0.068uF
220uF
5%
5%
20%
5%
20%
50V
50V
50V
50V
10V
C407
C408
C409
C411
C412
1-136-157-00
1-126-967-11
1-115-426-11
1-126-967-11
1-126-970-11
FILM
ELECT
ELECT
ELECT
ELECT
0.022uF
47uF
6800uF
47uF
330uF
5%
20%
20%
20%
20%
50V
16V
50
50V
50V
C413
C414
C415
C416
C417
1-124-903-11
1-137-420-11
1-126-025-11
1-126-967-11
1-126-964-11
ELECT
FILM
ELECT
ELECT
ELECT
1uF
0.047uF
330uF
47uF
10uF
20%
10%
20%
20%
20%
50V
100V
25V
16V
50V
C418
C419
C430
C451
C452
1-126-964-11
1-164-077-11
1-126-965-11
1-136-163-00
1-136-163-00
ELECT
CERAMIC
ELECT
FILM
FILM
10uF
220PF
22uF
0.068uF
0.068uF
20%
10%
20%
5%
5%
50V
50V
50V
50V
50V
C454
C459
C464
C465
C468
1-124-920-11
1-115-426-11
1-137-420-11
1-126-025-11
1-126-967-11
ELECT
ELECT
FILM
ELECT
ELECT
330uF
6800uF
0.047uF
330uF
47uF
20%
20%
10%
20%
20%
50V
50
100V
25V
50V
C469
1-164-077-11 CERAMIC
220PF
10%
50V
Q401
Q402
Q403
Q404
Q405
8-729-104-18
8-729-104-91
8-729-232-45
8-729-232-46
8-729-140-84
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC3514-Q
2SA1383
2SK1529-Y
2SJ200-Y
2SC1841-PAFAEA
Q406B
Q407
Q430
Q451
Q452
8-729-209-15
8-729-281-54
8-729-119-76
8-729-104-18
8-729-104-91
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SD2012
2SC1815-BL
2SA1175-HFE
2SC3514-Q
2SA1383
Q453
Q454
Q455
8-729-232-45 TRANSISTOR 2SK1529-Y
8-729-232-46 TRANSISTOR 2SJ200-Y
8-729-140-84 TRANSISTOR 2SC1841-PAFAEA
< RESISTOR >
R401
R402
R403
R404
R405
1-249-393-11
1-249-393-11
1-249-405-11
1-249-405-11
1-247-745-11
CARBON
CARBON
CARBON
CARBON
CARBON
10
10
100
100
330
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/2W
! R406
! R407
R408
R409
R410
1-208-601-11
1-208-601-11
1-259-428-11
1-259-444-11
1-259-432-11
WIREWOUND
WIREWOUND
CARBON
CARBON
CARBON
0.1
0.1
1K
4.7K
1.5K
10%
10%
5%
5%
5%
2W
F
2W
F
1/6W
1/6W
1/6W
R411
R412
R413
R414
R415
1-249-162-11
1-259-488-11
1-259-452-11
1-259-484-11
1-259-460-11
CARBON
CARBON
CARBON
CARBON
CARBON
10
330K
10K
220K
22K
5%
5%
5%
5%
5%
1/3W
1/6W
1/6W
1/6W
1/6W
R416
R417
R418
R420
R430
1-259-480-11
1-259-456-11
1-259-444-11
1-259-460-11
1-259-452-11
CARBON
CARBON
CARBON
CARBON
CARBON
150K
15K
4.7K
22K
10K
5%
5%
5%
5%
5%
1/6W
1/6W
1/6W
1/6W
1/6W
R431
R451
R452
R453
R454
1-259-470-11
1-249-393-11
1-249-393-11
1-249-405-11
1-249-405-11
CARBON
CARBON
CARBON
CARBON
CARBON
56K
10
10
100
100
5%
5%
5%
5%
5%
1/6W
1/4W
1/4W
1/4W
1/4W
1-247-745-11
1-208-601-11
1-208-601-11
1-259-444-11
1-259-432-11
CARBON
WIREWOUND
WIREWOUND
CARBON
CARBON
330
0.1
0.1
4.7K
1.5K
5%
10%
10%
5%
5%
1/2W
2W
F
2W
F
1/6W
1/6W
10
330K
5%
5%
1/3W
1/6W
< CONNECTOR >
CN401
CN402
CN405
CN406
CN407
1-691-768-11
1-691-766-11
1-691-768-11
1-564-506-11
1-564-506-11
PLUG (MICRO CONNECTOR) 6P
PLUG (MICRO CONNECTOR) 4P
PLUG (MICRO CONNECTOR) 6P
PLUG, CONNECTOR 3P
PLUG, CONNECTOR 3P
CN403B 1-691-765-21 PLUG (MICRO CONNECTOR) 3P
CN404B 1-691-765-11 PLUG (MICRO CONNECTOR) 3P
< DIODE >
D401
D409
D410
D411
D412
8-719-024-99
8-719-024-99
8-719-024-99
8-719-024-99
8-719-302-38
11ES2-NTA2B
11ES2-NTA2B
11ES2-NTA2B
11ES2-NTA2B
RBV-602-01
R455
! R456
! R457
R459
R460
D413
D451
8-719-933-39 DIODE HZS6C1L
8-719-024-99 DIODE 11ES2-NTA2B
R461
R462
DIODE
DIODE
DIODE
DIODE
DIODE
< IC >
IC401
1-249-162-11 CARBON
1-259-488-11 CARBON
**************************************************************
8-759-111-68 IC uPC1237HA
— 24 —
The components identified by mark !
or dotted line with mark ! are critical
for safety.
Replace only with part number specified.
OUTLET
Ref. No.
Part No.
Description
Remark
Ref. No.
Part No.
1-660-573-11 OUTLET BOARD
*************
*
! CNJ801 1-526-794-11 OUTLET,AC (AC OUTLET SWITCHED 100W MAX)
! CNJ802 1-526-794-11 OUTLET,AC (AC OUTLET SWITCHED 100W MAX)
! CNJ803 1-526-794-11 OUTLET,AC (AC OUTLET SWITCHED 100W MAX)
**************************************************************
A-4389-795-A PANEL BOARD, COMPLETE
**********************
< CAPACITOR >
C200
C201
C202
C203
C208
1-130-475-00
1-136-153-00
1-136-155-00
1-136-165-00
1-130-471-00
MYLAR
FILM
FILM
FILM
MYLAR
0.0022uF
0.01uF
0.015uF
0.1uF
0.001uF
5%
5%
5%
5%
5%
50V
50V
50V
50V
50V
C209
C210
C250
C251
C252
1-136-171-00
1-136-165-00
1-130-475-00
1-136-153-00
1-136-155-00
FILM
FILM
MYLAR
FILM
FILM
0.33uF
0.1uF
0.0022uF
0.01uF
0.015uF
5%
5%
5%
5%
5%
50V
50V
50V
50V
50V
C253
C258
C259
C260
C900
1-136-165-00
1-130-471-00
1-136-171-00
1-136-165-00
1-126-964-11
FILM
MYLAR
FILM
FILM
ELECT
0.1uF
0.001uF
0.33uF
0.1uF
10uF
5%
5%
5%
5%
20%
50V
50V
50V
50V
50V
C901
C902
C903
C906
C907
1-126-916-11
1-164-159-11
1-162-294-31
1-126-964-11
1-126-964-11
ELECT
CERAMIC
CERAMIC
ELECT
ELECT
1000uF
0.1uF
0.001uF
10uF
10uF
20%
10%
20%
20%
6.3V
50V
50V
50V
50V
C908
C909
C910
C912
C961
1-126-963-11
1-128-551-11
1-126-933-11
1-126-964-11
1-164-095-11
ELECT
ELECT
ELECT
ELECT
CERAMIC
4.7uF
22uF
100uF
10uF
0.01uF
20%
20%
20%
20%
10%
50V
63V
10V
50V
16V
C962
C963
1-164-095-11 CERAMIC
1-164-095-11 CERAMIC
0.01uF
0.01uF
10%
10%
16V
16V
< CONNECTOR >
CN455
CN900
CN901
CN902
* CN903
1-691-768-11
1-691-766-11
1-691-766-21
1-691-766-11
1-564-527-11
Description
Remark
< DIODE >
< CONNECTOR >
*
PANEL
PLUG (MICRO CONNECTOR) 6P
PLUG (MICRO CONNECTOR) 4P
PLUG (MICRO CONNECTOR) 4P
PLUG (MICRO CONNECTOR) 4P
PLUG, CONNECTOR
* CNP900 1-568-318-21 PLUG, CONNECTOR 6P
* CNP901 1-568-320-11 PLUG, CONNECTOR 8P
CNP902 1-774-936-11 CONNECTOR, BOARD TO BOARD 12P
D902
D903
D904
D905
D906
8-719-987-63
8-719-024-99
8-719-987-63
8-719-987-63
8-719-987-63
DIODE
DIODE
DIODE
DIODE
DIODE
1N4148M
11ES2-NTA2B
1N4148M
1N4148M
1N4148M
D907
D908
D910
D911
D912
8-719-987-63
8-719-987-63
8-719-987-63
8-719-987-63
8-719-987-63
DIODE
DIODE
DIODE
DIODE
DIODE
1N4148M
1N4148M
1N4148M
1N4148M
1N4148M
D913
D914
D915
D916
D919
8-719-985-59
8-719-987-63
8-719-987-63
8-719-987-63
8-719-987-63
DIODE
DIODE
DIODE
DIODE
DIODE
HZS4CLL-TA
1N4148M
1N4148M
1N4148M
1N4148M
< IC >
IC901
IC902
8-759-962-08 IC BA6208
8-759-392-41 IC TMP47C103N-JP47
< TRANSISTOR >
Q900
Q901
Q902
Q903
Q904
8-729-620-05
8-729-900-63
8-729-900-63
8-729-900-80
8-729-422-57
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC2603-EF
DTA124ES
DTA124ES
DTC114ES
UN4111
Q905
Q906
Q907
Q908
Q909
8-729-422-57
8-729-422-57
8-729-119-78
8-729-620-05
8-729-620-05
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
UN4111
UN4111
2SC2785-HFE
2SC2603-EF
2SC2603-EF
Q910
Q911
Q920
Q921
Q922
8-729-201-53
8-729-142-36
8-729-422-57
8-729-620-05
8-729-620-05
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SA1015-GR
BN1L3Z
UN4111
2SC2603-EF
2SC2603-EF
Q923
8-729-119-76 TRANSISTOR 2SA1175-HFE
< RESISTOR >
R200
R201
R202
R203
R204
1-259-500-11
1-259-446-11
1-259-446-11
1-259-436-11
1-259-464-11
CARBON
CARBON
CARBON
CARBON
CARBON
1M
5.6K
5.6K
2.2K
33K
5%
5%
5%
5%
5%
1/6W
1/6W
1/6W
1/6W
1/6W
R205
R206
R207
R208
R209
1-259-446-11
1-259-500-11
1-259-456-11
1-259-456-11
1-259-500-11
CARBON
CARBON
CARBON
CARBON
CARBON
5.6K
1M
15K
15K
1M
5%
5%
5%
5%
5%
1/6W
1/6W
1/6W
1/6W
1/6W
R210
1-259-500-11 CARBON
1M
5%
1/6W
— 25 —
The components identified by mark !
or dotted line with mark ! are critical
for safety.
Replace only with part number specified.
PANEL
Ref. No.
PRO IND
Part No.
SP SW
Description
Remark
R220
R250
R251
R252
1-259-464-11
1-259-500-11
1-259-446-11
1-259-446-11
CARBON
CARBON
CARBON
CARBON
33K
1M
5.6K
5.6K
5%
5%
5%
5%
1/6W
1/6W
1/6W
1/6W
R253
R254
R255
R256
R257
1-259-436-11
1-259-464-11
1-259-446-11
1-259-500-11
1-259-456-11
CARBON
CARBON
CARBON
CARBON
CARBON
2.2K
33K
5.6K
1M
15K
5%
5%
5%
5%
5%
1/6W
1/6W
1/6W
1/6W
1/6W
R258
R259
R260
R270
R419
1-259-456-11
1-259-500-11
1-259-500-11
1-259-464-11
1-249-429-11
CARBON
CARBON
CARBON
CARBON
CARBON
15K
1M
1M
33K
10K
5%
5%
5%
5%
5%
1/6W
1/6W
1/6W
1/6W
1/4W
R902
R903
R905
R908
R909
1-249-429-11
1-249-429-11
1-249-429-11
1-249-429-11
1-249-429-11
CARBON
CARBON
CARBON
CARBON
CARBON
10K
10K
10K
10K
10K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R910
R911
R912
R913
R914
1-249-400-11
1-249-411-11
1-249-429-11
1-249-425-11
1-247-807-31
CARBON
CARBON
CARBON
CARBON
CARBON
39
330
10K
4.7K
100
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R917
R918
R919
R920
R921
1-249-433-11
1-249-423-11
1-249-423-11
1-249-429-11
1-249-429-11
CARBON
CARBON
CARBON
CARBON
CARBON
22K
3.3K
3.3K
10K
10K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R922
R923
R924
R927
R941
1-249-429-11
1-249-429-11
1-249-429-11
1-249-406-11
1-249-423-11
CARBON
CARBON
CARBON
CARBON
CARBON
10K
10K
10K
120
3.3K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R942
R943
R944
R950
R951
1-247-756-11
1-247-756-11
1-249-423-11
1-249-419-11
1-247-807-31
CARBON
CARBON
CARBON
CARBON
CARBON
2.2K
2.2K
3.3K
1.5K
100
5%
5%
5%
5%
5%
1/2W
1/2W
1/4W
1/4W
1/4W
R952
R953
R954
R958
R959
1-249-427-11
1-247-903-00
1-249-425-11
1-249-406-11
1-249-429-11
CARBON
CARBON
CARBON
CARBON
CARBON
6.8K
1M
4.7K
120
10K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R960
R961
R962
1-249-429-11 CARBON
1-249-429-11 CARBON
1-249-429-11 CARBON
10K
10K
10K
5%
5%
5%
1/4W
1/4W
1/4W
Ref. No.
Part No.
Description
Remark
< SWITCH >
S200
S201
S202
S901
1-571-828-11
1-762-387-11
1-571-112-21
1-692-974-11
SWITCH, PUSH(1 KEY) (SOURCE DIRECT)
SWITCH, PUSH (LOUDNESS)
SWITCH, PUSH (1 KEY) (SUBSONIC)
SWITCH, ROTARY (INPUT SELECTOR)
< VIBRATOR >
X900
1-577-358-21 VIBRATOR, CERAMIC (4.00MHz)
**************************************************************
1-660-567-11 PRO IND BOARD
**************
*
< CONNECTOR >
CN951
1-691-766-21 PLUG (MICRO CONNECTOR) 4P
< DIODE >
D900
8-719-313-48 DIODE SEL6210S-TH12 (PROTECTION)
< IC >
IC900
8-759-373-49 IC NJL54H400
< RESISTOR >
R900
RV200
RV201
RV202
1-223-933-21 RES, VAR, CARBON 250K/250K (BALANCE)
1-223-934-21 RES, VAR, CARBON 250K/250K (TREBLE)
1-223-935-21 RES, VAR, CARBON 900K/900K (BASS)
220
5%
1/4W
**************************************************************
1-660-564-11 SP SW BOARD
************
*
< VARIABLE RESISTOR >
1-249-409-11 CARBON
< CONNECTOR >
CN552
CN950
CN960
1-691-771-11 PLUG (MICRO CONNECTOR) 9P
1-691-766-11 PLUG (MICRO CONNECTOR) 4P
1-691-765-11 PLUG (MICRO CONNECTOR) 3P
< DIODE >
D701
8-719-987-63 DIODE 1N4148M
< RESISTOR >
R928
R929
R930
R931
R932
1-247-751-11
1-247-751-11
1-247-751-11
1-247-751-11
1-247-751-11
CARBON
CARBON
CARBON
CARBON
CARBON
820
820
820
820
820
5%
5%
5%
5%
5%
1/2W
1/2W
1/2W
1/2W
1/2W
R933
R934
R935
R936
R937
1-247-751-11
1-247-746-11
1-247-746-11
1-247-746-11
1-247-746-11
CARBON
CARBON
CARBON
CARBON
CARBON
820
390
390
390
390
5%
5%
5%
5%
5%
1/2W
1/2W
1/2W
1/2W
1/2W
R938
1-247-753-11 CARBON
1.2K
5%
1/2W
— 26 —
SP SW
Ref. No.
R939
Part No.
Description
1-247-753-11 CARBON
1.2K
5%
Remark
Ref. No.
1/2W
*
Part No.
SP TM
TRANS
Description
VOL
Remark
1-660-574-11 TRANS BOARD
************
< RELAY >
< TRANSFORMER >
RY701
1-515-614-11 RELAY
! T1
1-429-492-11 TRANSFORMER,POWER
< SWITCH >
**************************************************************
S900
1-762-654-11 SWITCH, ROTARY SLIDE (SPEAKERS)
1-660-565-11 VOL BOARD
**********
*
**************************************************************
< CAPACITOR >
1-660-571-11 SP TM BOARD
************
*
C904
1-136-165-00 FILM
0.1uF
5%
50V
5%
5%
1/4W
1/4W
1-533-233-11 HOLDER, FUSE
< CONNECTOR >
< CAPACITOR >
C501
1-164-159-11 CERAMIC
0.1uF
CN201 1-691-770-11 PLUG (MICRO CONNECTOR) 8P
CNJ900 1-568-317-11 SOCKET, CONNECTOR 6P
CNJ901 1-568-319-11 SOCKET, CONNECTOR 8P
50V
< CONNECTOR >
< TRANSISTOR >
CN503
CN802
CN804
* CN808
* CN809
1-566-212-11
1-564-321-00
1-580-230-11
1-564-321-21
1-565-792-11
PIN, CONNECTOR 3P
PIN, CONNECTOR 2P
PIN, CONNECTOR (PC BOARD) 2P
PIN, CONNECTOR 2P
PIN, CONNECTOR 2P
Q950
Q951
< RESISTOR >
R955
R956
< DIODE >
D501
D502
1-249-427-11 CARBON
1-249-427-11 CARBON
8-719-987-63 DIODE 1N4148M
8-719-987-63 DIODE 1N4148M
RV203
1-532-388-51 FUSE,TIMELAG (2.0A 250V)
1-532-464-51 FUSE,TIMELAG (2.5A 250V)
1-225-227-11 RES, VAR, CARBON 120K/120K (VOLUME)
**************************************************************
MISCELLANEOUS
**************
< COIL >
L501
L551
1-411-906-11 COIL, AIR-CORE
1-411-906-11 COIL, AIR-CORE
< RESISTOR >
R501
R502
R551
R552
1-249-162-11
1-247-750-11
1-249-162-11
1-247-750-11
CARBON
CARBON
CARBON
CARBON
10
680
10
680
5%
5%
5%
5%
1/3W
1/2W
1/3W
1/2W
< RELAY >
RY501
RY502
6.8K
6.8K
< VARIABLE RESISTOR >
< FUSE >
! F801
! F802
8-729-141-26 TRANSISTOR 2SC3622A-LK
8-729-141-26 TRANSISTOR 2SC3622A-LK
1-515-921-11 RELAY (12V)
1-515-921-11 RELAY (12V)
! CNJ801
! CNJ802
! CNJ803
! CNP801
! F801
1-526-794-11
1-526-794-11
1-526-794-11
1-777-185-11
1-532-388-51
OUTLET, AC (AC OUTLET SWITCHED 100W MAX)
OUTLET, AC (AC OUTLET SWITCHED 100W MAX)
OUTLET, AC (AC OUTLET SWITCHED 100W MAX)
CORD, POWER
FUSE, TIME LAG (2.0A 250V)
! F802
Q403
Q404
Q453
Q454
1-532-464-51
8-729-232-45
8-729-232-46
8-729-232-45
8-729-232-46
FUSE, TIME LAG (2.5A 250V)
TRANSISTOR 2SK1529-Y
TRANSISTOR 2SJ200-Y
TRANSISTOR 2SK1529-Y
TRANSISTOR 2SJ200-Y
Q406B
! S1
! T1
8-729-209-15 TRANSISTOR 2SD2012
1-554-920-11 SWITCH, PUSH (AC POWER)(1 KEY)(POWER)
1-429-492-11 TRANSFORMER, POWER
< TERMINAL >
**************************************************************
* TM501
1-537-519-11 TERMINAL BOARD (SP) (SPEAKERS)
**************************************************************
— 27 —
The components identified by mark !
or dotted line with mark ! are critical
for safety.
Replace only with part number specified.
TA-FE600R
Ref. No.
Part No.
Description
Remark
ACCESSORIES & PACKING MATERIALS
********************************
*
1-473-656-11 REMOTE COMMANDER (RM-S316)
3-856-216-11 MANUAL, INSTRUCTION
(ENGLISH,FRENCE,SPANISH,PORTUGUESE) (AEP)
3-856-216-21 MANUAL, INSTRUCTION
(GERMAN,DUTCH,SWEDISH,ITALIAN) (AEP)
3-856-216-31 MANUAL, INSTRUCTION (GERMAN) (G)
4-981-575-01 CUSHION
*
4-981-643-01 COVER, BATTERY (For RM-S316)
4-982-294-01 INDIVIDUAL CARTON
Sony Corporation
9-960-695-11
Home A&V Products Company
— 28 —
English
96F097547-1
Printed in Germany
© 1996. 6
Published by Quality Engineering Dept.
(Shibaura)