Download TA-FA30ES
Transcript
TA-FA30ES SERVICE MANUAL AEP Model UK Model E Model Australian Model Chinese Model Photo: GOLD model SPECIFICATIONS System Power Amplifier: Pure-complementary SEPP MOS FET power amplifier with all stages directly coupled Preamplifier: Low-noise, high-gain equalizer amplifier Power section: Large-capacity power supply advanced STD Rated output 4 ohms, 120 W + 120 W (DIN 0.7%, 1 kHz) 8 ohms, 80 W + 80 W (DIN 0.7%, 1 kHz) Speaker Impedance 4 to 16 ohms Output bandwidth (8 ohms) 10 Hz to 100 kHz (at 40 W output, and high-frequency distortion rate of 0.08%) Total harmonic distortion 0.008% (at 8 ohms, 10 W output) Damping factor 100 (8 ohms, 1 kHz) Intermodulation (1M) distortion (60 Hz : 7 kHz = 4 : 1) 0.008% (8 ohms) Throughrate 125 V/µ sec, 250 V/µ sec (Inside) Residual noise Less than 100 µV (network A) Equalizer deviation PHONO MM: 20 Hz to 20 kHz, ± 5 dB Frequency response TUNER, CD, AUX, TAPE1/DAT, TAPE2/MD: 7 Hz to 100 kHz +0 – 3 dB Inputs Input sensitivity and impedance PHONO MC: 0.17 mV, 100 ohms MM: 2.5 mV, 50 kilohms TUNER, CD, AUX, TAPE1/DAT, TAPE2/MD: 150 mV, 20 kilohms Maximum input capability (1 kHz) PHONO MC: 9 mV MM: 150 mV Outputs Output level/impedance REC OUT 1, 2: 150 mV, 1 kilohm PHONES: 10 mW (at 8 ohms) Tone controls BASS (100 Hz): ± 7 dB TREBLE (10 kHz): ± 7 dB General Power requirements 230 V AC, 50/60 Hz Power consumption 220 W Dimensions (approx) (w/h/d) 430 × 150 × 415 mm incl. projecting parts and controls Mass (approx) 11.0 kg Supplied accessories Remote commander (remote ) RM-S326 (1) Sony batteries R6 (size-AA) (2) Design and specifications are subject to change without notice. S/N PHONO MC: 78 dB (network A, 0.5 mV) MM: 95 dB (network A, 5 mV) TUNER, CD, AUX, TAPE1/DAT, TAPE2/MD: 105 dB INTEGRATED STEREO AMPLIFIER MICROFILM TABLE OF CONTENTS 1. GENERAL Location of Controls ....................................................... 3 2. DISASSEMBLY ......................................................... 4 3. ELECTRICAL ADJUSTMENTS ......................... 6 4. DIAGRAMS 4-1. Notes for Printed Wiring Boards and Schematic Diagrams ................................................ 4-2. Printed Wiring Boards – INPUT Section – ................... 4-3. Schematic Diagram – INPUT Section – ......................... 4-4. Printed Wiring Boards – MAIN Section – .................... 4-5. Schematic Diagram – MAIN Section – .......................... 4-6. Printed Wiring Boards – PANEL Section – .................. 4-7. Schematic Diagram – PANEL Section – ....................... 4-8. Printed Wiring Boards – POWER Section – ................. 4-9. Schematic Diagram – POWER Section – ..................... 4-10. IC Pin Function Description ........................................... 8 9 11 13 15 17 19 21 23 26 5. EXPLODED VIEWS ................................................ 27 6. ELECTRICAL PARTS LIST ............................... 31 SAFETY-RELATED COMPONENT WARNING!! COMPONENTS IDENTIFIED BY MARK ! OR DOTTED LINE WITH MARK ! ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY. –2– SECTION 1 GENERAL LOCATION OF CONTROLS Front Panel 2 1 56 7 8 9 !º 4 3 1 2 3 4 5 6 7 8 9 !º !¡ !™ U (Power) switch and indicator TAPE MONITOR switch and indicator INPUT SELECTOR switch and indicator ATTENUATOR control PHONES jack Remote control sensor SPEAKERS switch BASS control TREBLE control BALANCE control SOURCE DIRECT switch and indicator MUTING swith and indicator 1 2 3 4 5 6 7 8 9 !º PHONO CARTRIDGE MM/MC SIGNAL GND y Mains lead SPEAKERS MAIN/BI-WIRE TAPE 1/DAT TAPE 2/MD AUX CD TUNER !¡ !™ Rear Panel –3– SECTION 2 DISASSEMBLY Note: Follow the disassembly procedure in the numerical order given. CASE, FRONT PANEL 1 two screws (CASE 3 TP2) 1 screw (CASE 3 TP2) 2 case (413235) 1 two screws (CASE 3 TP2) 5 three screws (3 × 8) 1 two screws (CASE 3 TP2) 6 front panel 3 knob (SEL) 4 knob (VOL) 5 four screws (3 × 8) SUB PANEL SECTION 7 two screws (3 × 8) 6 connector (CN2) 4 connector (CN700) 5 connector (CN503) 8 sub panel section 1 connector (CN103) 7 two screws (3 × 8) 7 four screws (3 × 8) 7 two screws (3 × 8) 7 three screws (3 × 8) 3 connector (CN303) 2 connector (CN102) –4– MAIN BOARD 5 three screws 5 four screws (3 × 8) (3 × 8) 2 connector (CN752) 6 four screws (3 × 8) 4 three screws (BV/RING) 5 four screws (3 × 8) 3 connector (CN104) 7 main board 1 connector (CN751) –5– SECTION 3 ELECTRICAL ADJUSTMENTS Bias Adjustment 1. Rotate fully the bias adjusting semi-fixed resistors (RV500, RV600) to the MIN position (counterclockwise). 2. Connect a digital voltmeter to the CN500 and CN600. 1 pin 3 pin CN500 + – CN600 – + 3. Set the slidack to 0 V, and press the U button (ON) on the set. 4. Raise gradually the slidack voltage up to the rated voltage (230 V). 5. At this time, confirm that the SP relay is turned on (it will click), and at the same time, the LED on the U button changes from red to green. 6. Adjust the RV500 and RV600 so that a reading of digital voltmeter is 10 mV ± 2 mV. 7. Return the slidack to 0 V, and press the U button (OFF) on the set. Adjustment Location: MAIN Board (Component Side) C720 1 3 CN500 RV500 C721 Q507 RV600 Q607 –6– 1 3 CN600 SECTION 4 DIAGRAMS • Circuit Boards Location 4-1. NOTE FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS (In addition to this, the necessary note is printed in each block.) Note on Schematic Diagram: • All capacitors are in µF unless otherwise noted. pF: µµF 50 WV or less are not indicated except for electrolytics and tantalums. • All resistors are in Ω and 1/4 W or less unless otherwise specified. • 2 : nonflammable resistor. • 5 : fusible resistor. • C : panel designation. PS board SP TM board MAIN board PHONO board • • HP board • • PANEL board Q B C NOTE: The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. • • • • POWER LED board Note on Printed Wiring Boards: • X : parts extracted from the component side. • b : Pattern from the side which enables seeing. • Indication of transistor. U : B+ Line. V : B– Line. H : adjustment for repair. Voltages and waveforms are dc with respect to ground under no-signal conditions. no mark: POWER ON Voltages are taken with a VOM (Input impedance 10 MΩ). Voltage variations may be noted due to normal production tolerances. Waveforms are taken with a oscilloscope. Voltage variations may be noted due to normal production tolerances. Circled numbers refer to waveforms. Signal path. K: TUNER These are omitted. Q B INPUT board VOL board –7– C E These are omitted. LED board SW board E –8– TA-FA30ES 4-2. PRINTED WIRING BOARDS – INPUT Section – • See page 7 for circuit Boards Location. (Page 14) • Semiconductor Location Ref. No. D101 D103 D104 D105 D106 D107 D108 D109 D110 D151 D251 Location C-6 D-4 D-3 D-3 C-3 B-3 A-3 A-3 D-4 C-9 C-9 Ref. No. Q100 Q101 Q102 Q103 Q104 Q105 Q152 Q252 Location C-5 C-5 C-5 C-6 C-6 C-6 C-9 C-9 (Page 18) (Page 17) –9– – 10 – TA-FA30ES 4-3. SCHEMATIC DIAGRAM – INPUT Section – (Page 16) (Page 19) (Page 20) – 11 – – 12 – TA-FA30ES 4-4. PRINTED WIRING BOARDS – MAIN Section – (Page 9) • See page 7 for Circuit Boards Location. (Page 18) (Page 17) (Page 18) (Page 22) • Semiconductor Location Ref. No. Location Ref. No. Location Ref. No. D500 D501 D502 D503 D504 D505 D506 D511 D513 D600 D601 D602 D603 D604 D605 D-3 D-3 D-3 C-2 C-2 C-2 C-4 C-10 B-10 A-3 A-3 A-3 B-2 B-2 B-2 D606 D700 D701 D702 D703 D704 D720 D721 B-4 F-11 F-11 F-11 A-8 A-8 B-5 C-5 IC700 F-10 Q500 Q501 Q502 Q503 D-1 D-2 D-2 D-2 Q504 Q505 Q506 Q507 Q508 Q509 Q510 Q511 Q512 Q513 Q600 Q601 Q602 Q603 Q604 – 13 – Location D-2 D-3 C-1 C-3 D-4 D-4 C-5 E-7 E-4 D-6 A-1 A-2 A-2 B-2 B-2 Ref. No. Location Q605 Q606 Q607 Q608 Q609 Q610 Q611 Q612 Q613 Q700 Q701 Q702 Q703 B-3 B-1 B-3 B-4 B-4 B-5 A-4 A-7 A-6 F-10 F-11 A-8 A-8 (Page 22) – 14 – TA-FA30ES 4-5. SCHEMATIC DIAGRAM – MAIN Section – • See page 25 for IC Block Diagram. (Page 20) (Page 19) (Page 11) (Page 19) (Page 24) (Page 24) The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. – 15 – – 16 – TA-FA30ES 4-6. PRINTED WIRING BOARDS – PANEL Section – • See page 7 for Circuit Boards Location. (Page 10) (Page 13) • Semiconductor Location – PANEL Board – (Page 13) (Page 10) • Semiconductor Location – LED Board – Ref. No. D914 D915 D916 D917 D918 D919 D920 D921 D922 (Page 13) – 17 – Location B-4 B-4 A-4 A-3 A-2 B-2 C-2 C-1 C-5 – 18 – Ref. No. Location D901 D902 D903 D904 D905 D906 D907 D908 D910 D911 D912 D923 D924 B-6 B-6 B-6 B-6 B-6 B-6 B-6 B-11 A-5 B-9 A-6 A-4 A-4 IC901 IC902 IC903 IC905 B-7 B-9 B-10 B-9 Q901 Q902 Q903 Q904 Q905 Q906 Q911 Q912 B-6 C-12 C-12 C-12 A-4 A-4 B-9 B-9 TA-FA30ES 4-7. SCHEMATIC DIAGRAM – PANEL Section – • See page 25 for IC Block Diagram. • Waveform 1 IC901 #™ (XOUT) 4.4 Vp-p 8 MHz (Page 16) (Page 15) (Page 16) (Page 11) (Page 11) – 19 – – 20 – TA-FA30ES 4-8. PRINTED WIRING BOARDS – POWER Section – • See page 7 for Circuit Boards Location. (Page 14) (Page 14) – 21 – – 22 – TA-FA30ES 4-9. SCHEMATIC DIAGRAM – POWER Section – (Page 16) (Page 15) The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. – 23 – – 24 – • IC Block Diagrams 4-10. IC700 • PANEL BOARD IC901 TMP47C200BN-H351 (SYSTEM CONTROLLER) µPC1237HA (SP TM BOARD) IC PIN FUNCTION DESCRIPTION Pin No. Pin Name I/O 1 RCL O Serial clock signal output to the EEPROM (IC902) 2 RDT I/O Two-way data bus with the EEPROM (IC902) 3 VDW O Volume motor drive signal output to the BA6208 (IC903) (for volume down direction) “H” active 4 VUP O Volume motor drive signal output to the BA6208 (IC903) (for volume up direction) “H” active 5 CD O Function relay (for CD) drive signal output terminal “H”: relay on (CD on) 6 MUT O Muting control signal output terminal “H”: muting on Not used (pull up) 7 AUX O Function relay (for AUX) drive signal output terminal “H”: relay on (AUX on) 8 — — Not used (fixed at “L”) 9 T2 O Function relay (for TAPE2/MD) drive signal output terminal “H”: relay on (TAPE2/MD on) 10 T1 O Function relay (for TAPE1/DAT) drive signal output terminal “H”: relay on (TAPE1/DAT on) 11 SW0 I Input selector switch (S903) input terminal “H”: TAPE1/DAT, “L”: other function 12 SW1 I Input selector switch (S903) input terminal “H”: TAPE2/MD, “L”: other function 13 SW2 I Input selector switch (S903) input terminal “H”: AUX, “L”: other function 14 SW3 I Input selector switch (S903) input terminal “H”: CD, “L”: other function 15 SW4 I Input selector switch (S903) input terminal “H”: TUNER, “L”: other function 16 SW5 I Input selector switch (S903) input terminal “H”: PHONO, “L”: other function 17 PHONO O Function LED (PHONO) drive signal output terminal “L”: LED on 18 TUNER O Function LED (TUNER) drive signal output terminal “L”: LED on 19 CD O Function LED (CD) drive signal output terminal “L”: LED on 20 AUX O Function LED (AUX) drive signal output terminal “L”: LED on 21 GND — Ground terminal 22 — — Not used (open) 23 T2 O Function LED (TAPE2/MD) drive signal output terminal “L”: LED on OVER LOAD DET VCC ON MUTE F/F OFFSET DET LATCH/ AUTORESET AC OFF DET VCC 1 2 IC903 3 4 5 6 7 8 BA6208 (PANEL BOARD) MOTOR DRIVE SWITCH MOTOR DRIVE SWITCH 1 2 3 4 5 6 7 8 9 NC INPUT 1 INPUT 2 NC GND Vcc OUTPUT 2 OUTPUT1 NC REG – 25 – Function 24 T1 O Function LED (TAPE1/DAT) drive signal output terminal “L”: LED on 25 to 29 — — Not used (fixed at “L”) 30 TEST — Not used (open) 31 XIN I System clock input terminal (8 MHz) 32 XOUT O System clock output terminal (8 MHz) 33 RESET I System reset signal input from the reset signal generator (IC905) “L”: reset For several hundreds msec. after the power supply rises, “L” is input, then it changes to “H” 34 HOLD I Cancellation of hold mode signal “H”: start 35 TUNER O Function relay (for TUNER) drive signal output terminal “H”: relay on (TUNER on) 36 PHONO O Function relay (for PHONO) drive signal output terminal “H”: relay on (PHONO on) 37 SIRCS I Remote control signal input from the remote control receiver (IC904) 38 to 41 — — Not used (fixed at “L”) 42 +5V — Power supply terminal (+5V) – 26 – SECTION 5 EXPLODED VIEWS NOTE: • -XX and -X mean standardized parts, so they may have some difference from the original one. • Color Indication of Appearance Parts Example: KNOB, BALANCE (WHITE) . . . (RED) ↑ ↑ Parts Color Cabinet's Color (1) • Items marked “*” are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. • The mechanical parts with no reference number in the exploded views are not supplied. • Accessories and packing materials are given in the last of the electrical parts list. The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. CASE, FRONT PANEL SECTION-1 10 10 11 10 10 1 not supplied 12 not supplied 1 4 5 3 13 1 6 1 14 not supplied 1 13 4 9 2 14 1 7 8 not supplied 1 Ref. No. Part No. Description 1 2 2 3 3 4-967-961-01 4-999-428-01 4-999-428-11 4-942-568-41 4-942-568-51 SCREW (3X8) PANEL, FRONT (BLACK) PANEL, FRONT (GOLD) EMBLEM (NO.5), SONY (BLACK) EMBLEM (NO.5), SONY (GOLD) * 4 5 5 6 6 X-4950-462-1 4-975-105-01 4-975-105-31 4-999-429-01 4-999-429-11 LENS ASSY, LED WINDOW, RAY CATCHER (BLACK) WINDOW, RAY CATCHER (GOLD) BASE (L), PANEL (BLACK) BASE (L), PANEL (GOLD) 7 7 4-999-433-01 KNOB (SEL) (BLACK) 4-999-433-11 KNOB (SEL) (GOLD) Remark Ref. No. Part No. Description 8 8 9 9 10 4-999-432-01 4-999-432-11 4-999-430-01 4-999-430-11 4-210-291-01 KNOB (VOL) (BLACK) KNOB (VOL) (GOLD) BASE (R), PANEL (BLACK) BASE (R), PANEL (GOLD) SCREW (CASE 3 TP2) (BLACK) 10 * 11 * 11 12 13 4-210-291-11 4-999-439-01 4-999-439-21 1-506-113-00 X-4949-759-1 SCREW (CASE 3 TP2) (GOLD) CASE (413235) (BLACK) CASE (413235) (GOLD) SHORT PLUG FOOT ASSY 14 – 27 – 7-685-885-09 SCREW +BVTT 4X16 (S) Remark (2) FRONT PANEL SECTION-2 51 57 not supplied S1 not supplied 52 56 51 supplied with J800 54 53 not supplied 51 58 51 not supplied 61 supplied with S903 55 56 Supplied with S901, RV303, RV302, RV301 59 56 supplied with RV304 60 62 The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. Ref. No. Part No. Description 51 * 52 53 53 * 54 4-967-961-01 1-669-483-11 3-024-055-01 3-024-055-11 1-669-481-11 SCREW (3X8) HP BOARD BUTTON (POWER) (U) (BLACK) BUTTON (POWER) (U) (GOLD) POWER LED BOARD 55 55 56 X-4949-758-1 KNOB (BAL) ASSY (BLACK) X-4949-761-1 KNOB (BAL) ASSY (GOLD) 7-685-751-09 SCREW +PTT 3X6 (S) Remark Ref. No. Part No. Description * 57 58 58 * 59 * 60 A-4407-634-A 4-970-146-01 4-970-146-21 1-669-480-11 1-669-484-11 PANEL BOARD, COMPLETE BUTTON (BLCAK) BUTTON (GOLD) VOL BOARD SW BOARD 61 * 62 ! S1 4-976-796-01 KNOB (A), LEVER 1-669-482-11 LED BOARD 1-554-920-11 SWITCH, PUSH (AC POWER) (1KEY) – 28 – Remark (3) CHASSIS SECTION-1 103 not supplied not supplied 103 103 104 106 104 107 103 102 not supplied 103 103 103 105 101 not supplied 106 109 not supplied 103 103 110 108 not supplied 101 T1 not supplied 111 111 103 112 The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. Ref. No. Part No. Description 101 * 102 103 104 * 105 4-967-960-01 1-669-473-11 4-967-961-01 4-211-985-01 A-4407-669-A SCREW (4X8) PS BOARD SCREW (3X8) SCREW (3X8), PC BOARD FITTING MAIN BOARD, COMPLETE 106 * 107 3-905-609-21 SCREW (TRANSISTOR) A-4407-670-A SP TM BOARD, COMPLETE Remark Ref. No. Part No. Description 108 109 * 110 111 * 112 4-970-145-01 4-970-146-01 A-4407-672-A 3-704-515-41 A-4407-635-A ESCUTCHEON (P) BUTTON (BLCAK) PHONO BOARD, COMPLETE SCREW (BV/RING) INPUT BOARD, COMPLETE ! T1 1-431-827-11 TRANSFORMER, POWER – 29 – Remark (4) CHASSIS SECTION-2 151 151 not supplied not supplied not supplied 151 152 151 151 not supplied 151 153 not supplied not supplied 151 not supplied CNP1 not supplied 154 151 not supplied not supplied not supplied not supplied 151 155 151 151 151 151 151 151 151 not supplied The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. Ref. No. Part No. Description 151 * 152 * 153 4-967-961-01 SCREW (3X8) 4-923-873-01 BRACKET, CORD STOPPER 3-703-244-00 BUSHING (2104), CORD Remark Ref. No. Part No. 154 * 155 ! CNP1 4-947-010-01 SCREW, FEEDER FIXED 4-999-426-01 PANEL, BACK 1-777-185-11 CORD, POWER – 30 – Description Remark SECTION 6 ELECTRICAL PARTS LIST NOTE: • Due to standardization, replacements in the parts list may be different from the parts specified in the diagrams or the components used on the set. • -XX and -X mean standardized parts, so they may have some difference from the original one. • RESISTORS All resistors are in ohms. METAL: Metal-film resistor. METAL OXIDE: Metal oxide-film resistor. F: nonflammable Ref. No. Part No. * 1-669-483-11 HP BOARD ********* • Items marked “*” are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. • SEMICONDUCTORS In each case, u: µ, for example: uA. . : µA. . uPA. . : µPA. . uPB. . : µPB. . uPC. . : µPC. . uPD. . : µPD. . • CAPACITORS uF: µF • COILS uH: µH Description Remark < JACK > J800 1-770-307-11 JACK (LARGE TYPE) (PHONES) ************************************************************ Ref. No. When indicating parts by reference number, please include the board. Description Remark Q101 Q102 Q103 Q104 8-729-620-05 8-729-620-05 8-729-620-05 8-729-620-05 TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR Q105 Q152 Q252 8-729-620-05 TRANSISTOR 2SC2603-EF 8-729-119-78 TRANSISTOR 2SC403SP-51 8-729-201-53 TRANSISTOR 2SA1015-GR 2SC2603-EF 2SC2603-EF 2SC2603-EF 2SC2603-EF < RESISTOR > < CAPACITOR > R151 R152 R153 R154 R155 1-259-239-11 1-259-239-11 1-259-239-11 1-259-239-11 1-259-239-11 CARBON CARBON CARBON CARBON CARBON 1M 1M 1M 1M 1M 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W R156 R157 R158 R159 R163 1-259-239-11 1-259-239-11 1-259-167-21 1-259-167-21 1-259-187-11 CARBON CARBON CARBON CARBON CARBON 1M 1M 1K 1K 6.8K 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W < DIODE > R164 R165 R166 R167 R251 1-249-212-11 1-249-212-11 1-249-212-11 1-249-212-11 1-259-239-11 CARBON CARBON CARBON CARBON CARBON 1.2K 1.2K 1.2K 1.2K 1M 5% 5% 5% 5% 5% 1/3W 1/3W 1/3W 1/3W 1/4W C158 C159 C160 C258 C259 1-126-024-11 1-126-023-11 1-126-052-11 1-126-024-11 1-126-023-11 ELECT ELECT ELECT ELECT ELECT 220uF 100uF 100uF 220uF 100uF 20% 20% 20% 20% 20% 25V 25V 50V 25V 25V C260 1-126-052-11 ELECT 100uF 20% 50V < CONNECTOR > CN102 CN103 CN104 INPUT The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. Part No. A-4407-635-A INPUT BOARD, COMPLETE ********************** * HP 1-691-768-11 PLUG (MICRO CONNECTOR) 6P 1-691-773-11 PLUG (MICRO CONNECTOR) 11P 1-691-765-11 PLUG (MICRO CONNECTOR) 3P D101 D103 D104 D105 D106 8-719-986-34 8-719-911-19 8-719-911-19 8-719-911-19 8-719-911-19 DIODE DIODE DIODE DIODE DIODE HZS15-1LTA 1SS119 1SS119 1SS119 1SS119 R252 R253 R254 R255 R256 1-259-239-11 1-259-239-11 1-259-239-11 1-259-239-11 1-259-239-11 CARBON CARBON CARBON CARBON CARBON 1M 1M 1M 1M 1M 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W D107 D108 D109 D110 D151 8-719-911-19 8-719-911-19 8-719-911-19 8-719-911-19 8-719-986-38 DIODE DIODE DIODE DIODE DIODE 1SS119 1SS119 1SS119 1SS119 HZS16-1LTA R257 R258 R259 R263 R264 1-259-239-11 1-259-167-21 1-259-167-21 1-259-187-11 1-249-212-11 CARBON CARBON CARBON CARBON CARBON 1M 1K 1K 6.8K 1.2K 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/3W D251 8-719-986-38 DIODE HZS16-1LTA R265 R266 R267 1-249-212-11 CARBON 1-249-212-11 CARBON 1-249-212-11 CARBON 1.2K 1.2K 1.2K 5% 5% 5% 1/3W 1/3W 1/3W < JACK > J102 J103 J104 1-778-517-11 JACK, PIN 6P (TUNER IN, CD IN, AUX IN) 1-784-934-21 JACK, PIN 4P (TAPE2/MD REC OUT, IN) 1-784-934-21 JACK, PIN 4P (TAPE1/DAT REC OUT, IN) < TRANSISTOR > Q100 8-729-620-05 TRANSISTOR 2SC2603-EF < RELAY > RY101 RY102 RY103 RY104 RY105 – 31 – 1-515-614-11 1-515-614-11 1-515-614-11 1-515-614-11 1-515-614-11 RELAY RELAY RELAY RELAY RELAY INPUT Ref. No. LED Part No. MAIN Description Remark RY106 1-515-614-11 RELAY RY107 1-515-614-11 RELAY RY108 1-515-614-11 RELAY ************************************************************ 1-669-482-11 LED BOARD ********** * Ref. No. Part No. 0.068uF 100uF 5% 20% 50V 16V C712 C713 C714 C720 C721 1-128-552-51 1-126-933-11 1-126-964-11 1-110-397-11 1-110-397-11 47uF 100uF 10uF 1000uF 1000uF 20% 20% 20% 20% 20% 63V 16V 50V 63V 63V ELECT ELECT ELECT ELECT ELECT < CONNECTOR > 1-563-381-11 SOCKET, CONNECTOR 11P CN500 CN503 CN600 CN700 < DIODE > D914 D915 D916 D917 D918 8-719-046-38 8-719-046-38 8-719-046-38 8-719-046-38 8-719-046-38 LED LED LED LED LED SEL5821A-TH8F (TAPE1/DAT) SEL5821A-TH8F (TAPE2/MD) SEL5821A-TH8F (AUX) SEL5821A-TH8F (CD) SEL5821A-TH8F (TUNER) D919 D920 D921 D922 8-719-046-38 8-719-046-38 8-719-046-38 8-719-046-38 LED LED LED LED SEL5821A-TH8F (PHONO) SEL5821A-TH8F (SOURCE DIRECT) SEL5821A-TH8F (MUTING) SEL5821A-TH8F (TAPE MONITOR) 1-564-506-11 1-564-510-11 1-564-506-11 1-691-768-11 PLUG, CONNECTOR 3P PLUG (MICRO CONNECTOR) 6P PLUG, CONNECTOR 3P PLUG (MICRO CONNECTOR) 6P < DIODE > < RESISTOR > R932 1-249-409-11 CARBON 220 5% 1/4W ************************************************************ A-4407-669-A MAIN BOARD, COMPLETE ********************* * Remark 1-136-163-00 FILM 1-126-023-11 ELECT < CONNECTOR > * CN806 Description C613 C617 < CAPACITOR > D500 D501 D502 D503 D504 8-719-911-19 8-719-911-19 8-719-911-19 8-719-933-39 8-719-911-19 DIODE DIODE DIODE DIODE DIODE D505 D506 D600 D601 D602 8-719-911-19 8-719-310-61 8-719-911-19 8-719-911-19 8-719-911-19 DIODE 1SS119 LED SEL1510C-D DIODE 1SS119 DIODE 1SS119 DIODE 1SS119 D603 D604 D605 D606 D703 8-719-933-39 8-719-911-19 8-719-911-19 8-719-310-61 8-719-933-39 DIODE HZS6C1L DIODE 1SS119 DIODE 1SS119 LED SEL1510C-D DIODE HZS6C1L 8-719-911-19 DIODE 1SS119 8-719-024-99 DIODE 11ES2-NTA2B 8-719-024-99 DIODE 11ES2-NTA2B C500 C501 C502 C503 C504 1-102-973-00 1-128-197-11 1-101-880-00 1-125-852-11 1-126-023-11 CERAMIC ELECT CERAMIC FILM ELECT 100PF 10uF 47PF 330PF 100uF 5% 20% 5% 5% 20% 50V 50V 50V 50V 16V D704 D720 D721 C505 C506 C507 C508 C509 1-107-587-11 1-126-023-11 1-126-023-11 1-126-023-11 1-125-842-11 CERAMIC ELECT ELECT ELECT FILM 7PF 100uF 100uF 100uF 4PF 0.5PF 20% 20% 20% 10% 500V 16V 16V 16V 50V JWH711 JWH712 JWH713 JWH714 JWH715 C510 C511 C512 C513 C517 1-128-200-11 1-102-978-00 1-136-163-00 1-136-163-00 1-126-023-11 ELECT CERAMIC FILM FILM ELECT 47uF 220PF 0.068uF 0.068uF 100uF 20% 5% 5% 5% 20% 63V 50V 50V 50V 16V C600 C601 C602 C603 C604 1-102-973-00 1-128-197-11 1-101-880-00 1-125-852-11 1-126-023-11 CERAMIC ELECT CERAMIC FILM ELECT 100PF 10uF 47PF 330PF 100uF 5% 20% 5% 5% 20% 50V 50V 50V 50V 16V C605 C606 C607 C608 C609 1-107-587-11 1-126-023-11 1-126-023-11 1-126-023-11 1-125-842-11 CERAMIC ELECT ELECT ELECT FILM 7PF 100uF 100uF 100uF 4PF 0.5PF 20% 20% 20% 10% 500V 16V 16V 16V 50V C610 C611 C612 1-128-200-11 ELECT 1-102-978-00 CERAMIC 1-136-163-00 FILM 47uF 220PF 0.068uF 20% 5% 5% 63V 50V 50V 1SS119 1SS119 1SS119 HZS6C1L 1SS119 < BRIDGE > 4-999-918-01 4-999-918-01 4-999-918-01 4-999-918-01 4-999-918-01 BRIDGE (PC-BOARD) BRIDGE (PC-BOARD) BRIDGE (PC-BOARD) BRIDGE (PC-BOARD) BRIDGE (PC-BOARD) < COIL > L720 L721 1-428-203-11 COIL, AIR-CORE 1-428-203-11 COIL, AIR-CORE < TRANSISTOR > Q500 Q501 Q502 Q503 Q504 8-729-045-15 8-729-201-53 8-729-201-53 8-729-201-53 8-729-104-91 TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR Q505 Q506 Q507 Q508 Q509 8-729-202-67 8-729-119-78 8-729-104-18 8-729-119-78 8-729-018-19 FET 2SK246-GR3 TRANSISTOR 2SC403SP-51 TRANSISTOR 2SC3514-Q TRANSISTOR 2SC403SP-51 TRANSISTOR 2SK2013-Y Q510 Q511 8-729-018-21 TRANSISTOR 2SJ313-Y 8-729-015-30 FET 2SK1530-Y – 32 – 2SC5169-FG 2SA1015-GR 2SA1015-GR 2SA1015-GR 2SA1383 MAIN Ref. No. Part No. Description Remark Q512 Q513 Q600 8-729-015-31 FET 2SJ201-Y 8-729-140-84 TRANSISTOR 2SC1841-PAFAEA 8-729-045-15 TRANSISTOR 2SC5169-FG Q601 Q602 Q603 Q604 Q605 8-729-201-53 8-729-201-53 8-729-201-53 8-729-104-91 8-729-202-67 TRANSISTOR 2SA1015-GR TRANSISTOR 2SA1015-GR TRANSISTOR 2SA1015-GR TRANSISTOR 2SA1383 FET 2SK246-GR3 Q606 Q607 Q608 Q609 Q610 8-729-119-78 8-729-104-18 8-729-119-78 8-729-018-19 8-729-018-21 TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR Q611 Q612 Q613 Q702 Q703 8-729-015-30 8-729-015-31 8-729-140-84 8-729-209-15 8-729-900-63 FET 2SK1530-Y FET 2SJ201-Y TRANSISTOR 2SC1841-PAFAEA TRANSISTOR 2SD2012 TRANSISTOR DTA124ES 2SC403SP-51 2SC3514-Q 2SC403SP-51 2SK2013-Y 2SJ313-Y Ref. No. Part No. R610 ! R611 1-259-183-11 CARBON 1-249-405-11 CARBON 4.7K 100 5% 5% 1/4W 1/4W F R612 R613 R614 R615 R616 1-259-183-11 1-259-171-21 1-249-496-11 1-259-143-21 1-247-749-11 CARBON CARBON CARBON CARBON CARBON 4.7K 1.5K 100K 100 560 5% 5% 5% 5% 5% 1/4W 1/4W 1/3W 1/4W 1/2W ! R617 ! R618 ! R619 ! R620 ! R621 1-247-696-11 1-247-696-11 1-247-745-11 1-249-405-11 1-249-405-11 CARBON CARBON CARBON CARBON CARBON 47 47 330 100 100 5% 5% 5% 5% 5% 1/4W 1/4W 1/2W 1/4W 1/4W ! R622 ! R623 R624 R625 R626 1-208-601-11 1-208-601-11 1-259-436-11 1-259-432-11 1-249-162-11 REGISTER REGISTER CARBON CARBON CARBON 0.1 0.1 2.2K 1.5K 10 10% 10% 5% 5% 5% 2W F 2W F 1/6W 1/6W 1/3W 220K 4.7K 5% 5% 1/6W 1/4W R627 R709 < RESISTOR > R500 R501 R502 R503 R504 1-259-167-21 1-259-215-21 1-259-151-21 1-259-151-21 1-259-151-21 CARBON CARBON CARBON CARBON CARBON 1K 100K 220 220 220 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W R505 R506 R507 R508 R509 1-259-179-21 1-259-151-21 1-259-151-21 1-249-490-11 1-259-175-11 CARBON CARBON CARBON CARBON CARBON 3.3K 220 220 27K 2.2K 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/3W 1/4W R510 ! R511 R512 R513 R514 1-259-183-11 1-249-405-11 1-259-183-11 1-259-171-21 1-249-496-11 CARBON CARBON CARBON CARBON CARBON 4.7K 100 4.7K 1.5K 100K 5% 5% 5% 5% 5% 1/4W 1/4W F 1/4W 1/4W 1/3W R515 R516 ! R517 ! R518 ! R519 1-259-143-21 1-247-749-11 1-247-696-11 1-247-696-11 1-247-745-11 CARBON CARBON CARBON CARBON CARBON 100 560 47 47 330 5% 5% 5% 5% 5% 1/4W 1/2W 1/4W F 1/4W F 1/2W F ! R520 ! R521 ! R522 ! R523 R524 1-249-405-11 1-249-405-11 1-208-601-11 1-208-601-11 1-259-436-11 CARBON CARBON REGISTER REGISTER CARBON 100 100 0.1 0.1 2.2K 5% 5% 10% 10% 5% 1/4W 1/4W 2W 2W 1/6W R525 R526 R527 R600 R601 1-259-432-11 1-249-162-11 1-259-484-11 1-259-167-21 1-259-215-21 CARBON CARBON CARBON CARBON CARBON 1.5K 10 220K 1K 100K 5% 5% 5% 5% 5% 1/6W 1/3W 1/6W 1/4W 1/4W R602 R603 R604 R605 R606 1-259-151-21 1-259-151-21 1-259-151-21 1-259-179-21 1-259-151-21 CARBON CARBON CARBON CARBON CARBON 220 220 220 3.3K 220 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W R607 R608 R609 1-259-151-21 CARBON 1-249-490-11 CARBON 1-259-175-11 CARBON 220 27K 2.2K 5% 5% 5% 1/4W 1/3W 1/4W PANEL Description 1-259-484-11 CARBON 1-249-425-11 CARBON Remark F F F F F < VARIABLE RESISTOR > RV500 1-241-762-11 RES, ADJ, CARBON 2.2K RV600 1-241-762-11 RES, ADJ, CARBON 2.2K ************************************************************ A-4407-634-A PANEL BOARD, COMPLETE ********************** * < CAPACITOR > F F F F C301 C302 C303 C304 C401 1-130-475-00 1-136-153-00 1-136-155-00 1-136-165-00 1-130-475-00 MYLAR FILM FILM FILM MYLAR 0.0022uF 0.01uF 0.015uF 0.1uF 0.0022uF 5% 5% 5% 5% 5% 50V 50V 50V 50V 50V C402 C403 C404 C901 C902 1-136-153-00 1-136-155-00 1-136-165-00 1-162-282-31 1-162-207-31 FILM FILM FILM CERAMIC CERAMIC 0.01uF 0.015uF 0.1uF 100PF 22PF 5% 5% 5% 10% 5% 50V 50V 50V 50V 50V C903 C904 C905 1-162-207-31 CERAMIC 1-164-159-11 CERAMIC 1-164-159-11 CERAMIC 22PF 0.1uF 0.1uF 5% 50V 50V 50V < CONNECTOR > * CN300 CN301 * CN804 * CN805 CN814 CN907 1-564-522-11 1-564-524-11 1-564-519-11 1-569-648-11 1-691-773-11 PLUG, CONNECTOR 7P PLUG, CONNECTOR 9P PLUG, CONNECTOR 4P PIN, CONNECTOR (PC BOARD) 11P PLUG (MICRO CONNECTOR) 11P 1-562-087-00 SOCKET, CONNECTOR 4P < DIODE > D901 D902 D903 D904 D905 – 33 – 8-719-911-19 8-719-911-19 8-719-911-19 8-719-911-19 8-719-911-19 DIODE DIODE DIODE DIODE DIODE 1SS119 1SS119 1SS119 1SS119 1SS119 The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. PANEL Ref. No. PHONO Part No. Description D906 D907 D908 D910 D911 8-719-911-19 8-719-911-19 8-719-911-19 8-719-986-56 8-719-200-82 DIODE DIODE DIODE DIODE DIODE Remark D912 D923 D924 8-719-911-19 DIODE 1SS119 8-719-911-19 DIODE 1SS119 8-719-911-19 DIODE 1SS119 Ref. No. 1SS119 1SS119 1SS119 HZS24-3LTA 11ES2 < IC > IC901 IC902 IC903 IC905 8-759-352-00 8-759-188-67 8-759-962-08 8-759-635-63 IC IC IC IC TMP47C200BN-H351 X24C01P-S BA6208 M51943BSL < TRANSISTOR > Q901 Q902 Q903 Q904 Q905 8-729-900-63 8-729-900-63 8-729-900-63 8-729-900-63 8-729-201-53 TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR DTA124ES DTA124ES DTA124ES DTA124ES 2SA1015-GR Q906 Q911 Q912 8-729-620-05 TRANSISTOR 2SC2603-EF 8-729-900-63 TRANSISTOR DTA124ES 8-729-119-76 TRANSISTOR 2SA1175-HFE < RESISTOR > R302 R303 R304 R305 R306 1-259-502-11 1-259-183-11 1-259-171-21 1-259-502-11 1-259-199-11 CARBON CARBON CARBON CARBON CARBON 4.7M 4.7K 1.5K 4.7M 22K 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W R307 R308 R309 R402 R403 1-259-183-11 1-259-183-11 1-259-199-11 1-259-502-11 1-259-183-11 CARBON CARBON CARBON CARBON CARBON 4.7K 4.7K 22K 4.7M 4.7K 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W R404 R405 R406 R407 R408 1-259-171-21 1-259-502-11 1-259-199-11 1-259-183-11 1-259-183-11 CARBON CARBON CARBON CARBON CARBON 1.5K 4.7M 22K 4.7K 4.7K 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W R409 R901 R902 R903 R904 1-259-199-11 1-249-433-11 1-249-433-11 1-249-433-11 1-249-433-11 CARBON CARBON CARBON CARBON CARBON 22K 22K 22K 22K 22K 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W R905 R906 R907 R908 R909 1-249-433-11 1-249-433-11 1-249-425-11 1-249-425-11 1-249-425-11 CARBON CARBON CARBON CARBON CARBON 22K 22K 4.7K 4.7K 4.7K 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W R910 R911 R912 R913 R914 1-249-429-11 1-249-429-11 1-249-433-11 1-249-433-11 1-249-429-11 CARBON CARBON CARBON CARBON CARBON 10K 10K 22K 22K 10K 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W R915 R916 1-249-433-11 CARBON 1-249-425-11 CARBON 22K 4.7K 5% 5% 1/4W 1/4W Part No. Description Remark R917 R918 R919 1-249-429-11 CARBON 1-249-429-11 CARBON 1-249-429-11 CARBON 10K 10K 10K 5% 5% 5% 1/4W 1/4W 1/4W R920 R921 R922 R923 R924 1-249-429-11 1-249-429-11 1-249-429-11 1-247-807-31 1-247-807-31 CARBON CARBON CARBON CARBON CARBON 10K 10K 10K 100 100 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W R925 R926 R927 R928 R929 1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31 1-247-753-11 CARBON CARBON CARBON CARBON CARBON 100 100 100 100 1.2K 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/2W R930 R933 R934 R935 R936 1-247-843-11 1-247-753-11 1-249-409-11 1-249-409-11 1-247-752-11 CARBON CARBON CARBON CARBON CARBON 3.3K 1.2K 220 220 1K 5% 5% 5% 5% 5% 1/4W 1/2W 1/4W 1/4W 1/2W R937 R938 R939 R940 R941 1-247-753-11 1-247-753-11 1-247-752-11 1-249-435-11 1-249-400-11 CARBON CARBON CARBON CARBON CARBON 1.2K 1.2K 1K 33K 39 5% 5% 5% 5% 5% 1/2W 1/2W 1/2W 1/4W 1/4W R942 R999 1-247-843-11 CARBON 1-249-433-11 CARBON 3.3K 22K 5% 5% 1/4W 1/4W < VARIABLE RESISTOR > RV301 RV302 RV303 1-225-615-11 RES, VAR, CARBON 250K/250K (BALANCE) 1-225-614-11 RES, VAR, CARBON 250K/250K (TREBLE) 1-225-613-11 RES, VAR, CARBON 900K/900K (BASS) < SWITCH > S301 S302 S901 S903 1-571-828-11 1-762-394-11 1-771-506-11 1-762-183-11 SWITCH, PUSH (1 KEY) (SOURCE DIRECT) SWITCH, PUSH (1 KEY) (MUTING) SWITCH, ROTARY (SPEAKERS) SWITCH, ROTARY (INPUT SELECTOR) < VIBRATOR > X900 1-579-223-11 OSCILLATOR, CERAMIC (8MHz) ************************************************************ A-4407-672-A PHONO BOARD, COMPLETE *********************** * < CAPACITOR > C150 C151 C152 C153 C154 1-102-978-00 1-126-059-11 1-101-880-00 1-106-359-00 1-126-024-11 CERAMIC ELECT CERAMIC MYLAR ELECT 220PF 10uF 47PF 4700PF 220uF 5% 20% 5% 5% 20% 50V 50V 50V 200V 16V C155 C156 C157 C170 C171 1-130-341-00 1-130-971-00 1-126-059-11 1-126-023-11 1-136-165-00 FILM FILM ELECT ELECT FILM 0.056uF 0.016uF 10uF 100uF 0.1uF 3% 3% 20% 20% 5% 100V 100V 50V 25V 50V C172 C250 C251 1-136-165-00 FILM 1-102-978-00 CERAMIC 1-126-059-11 ELECT 0.1uF 220PF 10uF 5% 5% 20% 50V 50V 50V – 34 – PHONO Ref. No. Part No. Description Remark C252 C253 1-101-880-00 CERAMIC 1-106-359-00 MYLAR 47PF 4700PF 5% 5% 50V 200V C254 C255 C256 C257 1-126-024-11 1-130-341-00 1-130-971-00 1-126-059-11 220uF 0.056uF 0.016uF 10uF 20% 3% 3% 20% 16V 100V 100V 50V ELECT FILM FILM ELECT Ref. No. Part No. Description 1-669-481-11 POWER LED BOARD **************** * < CONNECTOR > 1-691-768-11 PLUG (MICRO CONNECTOR) 6P CN900 1-691-767-11 PLUG (MICRO CONNECTOR) 5P < DIODE > 8-719-985-97 DIODE HZS7B1LTA D913 8-719-313-40 LED < IC > IC150 SEL1516W (POWER) < IC > 8-759-701-25 IC NJM2068D-D IC904 8-749-014-66 IC NJL56H400A < JACK > J150 Remark S101 1-762-395-11 SWITCH, PUSH (1 KEY) (PHONO CARTRIDGE) ************************************************************ < DIODE > D170 PS < SWITCH > < CONNECTOR > CN151 POWER LED < RESISTOR > 1-784-933-11 JACK 2P (PHONO IN) R931 1-249-408-11 CARBON 180 5% 1/4W ************************************************************ < TRANSISTOR > 1-669-473-11 PS BOARD ********* * Q150 Q151 Q250 Q251 8-729-354-52 8-729-354-52 8-729-354-52 8-729-354-52 TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR 2SC2545 2SC2545 2SC2545 2SC2545 < CAPACITOR > C750 C751 C756 < RESISTOR > R151 R152 R153 R154 R155 1-249-911-11 1-259-215-21 1-259-215-21 1-259-161-21 1-259-161-21 CARBON CARBON CARBON CARBON CARBON 330 100K 100K 560 560 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W R156 R157 R158 R159 R160 1-259-143-21 1-259-191-21 1-249-900-11 1-249-844-11 1-259-320-11 CARBON CARBON CARBON CARBON CARBON 100 10K 110 56K 4.7K 5% 5% 5% 1% 1% 1/4W 1/4W 1/4W 1/2W 1/2W R161 R162 R168 R169 R170 1-259-239-11 1-259-167-21 1-259-143-21 1-259-115-11 1-259-171-21 CARBON CARBON CARBON CARBON CARBON 1M 1K 100 6.8 1.5K 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W R251 R252 R253 R254 R255 1-249-911-11 1-259-215-21 1-259-215-21 1-259-161-21 1-259-161-21 CARBON CARBON CARBON CARBON CARBON 330 100K 100K 560 560 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W R256 R257 R258 R259 R260 1-259-143-21 1-259-191-21 1-249-900-11 1-249-844-11 1-259-320-11 CARBON CARBON CARBON CARBON CARBON 100 10K 110 56K 4.7K 5% 5% 5% 1% 1% 1/4W 1/4W 1/4W 1/2W 1/2W R261 R262 R268 R269 1-259-239-11 1-259-167-21 1-259-143-21 1-259-115-11 CARBON CARBON CARBON CARBON 1M 1K 100 6.8 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1-125-939-11 ELECT 1-125-939-11 ELECT 1-136-880-11 FILM 10000uF 10000uF 2.2uF 20% 20% 10% 56V 56V 160V < CONNECTOR > CN1 CN2 CN3 * CN750 * CN751 CN752 1-774-108-11 1-564-321-00 1-564-321-00 1-564-687-11 1-766-920-11 PIN, CONNECTOR (PC BOARD) PIN, CONNECTOR 2P PIN, CONNECTOR 2P PIN, CONNECTOR 3P PIN, CONNECTOR 4P 1-770-832-11 CONNECTOR, BOARD TO BOARD 6P < DIODE > D751 D752 D753 D754 8-719-230-02 8-719-230-02 8-719-230-02 8-719-230-02 DIODE DIODE DIODE DIODE 30DF2 30DF2 30DF2 30DF2 < FUSE > ! F1 1-532-504-51 FUSE T4AL/250V < FUSE HOLDER > FH1 FH2 1-533-233-11 HOLDER, FUSE 1-533-233-11 HOLDER, FUSE < RESISTOR > ! R750 1-212-974-00 FUSIBLE 47 5% 1/2W F ************************************************************ – 35 – The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. TA-FA30ES SP TM SW VOL Ref. No. Part No. * A-4407-670-A SP TM BOARD, COMPLETE ********************** Description Remark Ref. No. RY503 Part No. Description Remark 1-515-920-11 RELAY (24V) < TERMINAL > < CAPACITOR > TM501 C700 C701 C702 C703 C704 1-126-965-11 1-136-163-00 1-124-995-11 1-136-157-00 1-104-664-11 ELECT FILM ELECT FILM ELECT 22uF 0.068uF 220uF 0.022uF 47uF 20% 5% 20% 5% 20% 50V 50V 10V 50V 16V C705 C706 C707 C708 C709 1-104-664-11 1-137-150-11 1-137-150-11 1-128-578-11 1-128-556-11 ELECT MYLAR MYLAR ELECT ELECT 47uF 0.01uF 0.01uF 1uF 1000uF 20% 10% 10% 20% 20% 16V 100V 100V 100V 63V C710 C711 1-128-553-11 ELECT 1-128-582-11 ELECT 220uF 10uF 20% 20% 63V 63V 1-537-235-11 TERMINAL BOARD (SP) (SPEAKERS MAIN, BI-WIRE) ************************************************************ < CONNECTOR > CN908 1-560-941-11 PIN, CONNECTOR 4P < SWITCH > S902 1-762-165-11 SWITCH, LEVER SLIDE (TAPE MONITOR) ************************************************************ < CONNECTOR > CN702 1-669-484-11 SW BOARD ********* * 1-669-480-11 VOL BOARD ********** * 1-770-831-11 CONNECTOR, BOARD TO BOARD 6P < CAPACITOR > < DIODE > D511 D513 D700 D701 D702 8-719-911-19 8-719-911-19 8-719-024-99 8-719-024-99 8-719-024-99 DIODE DIODE DIODE DIODE DIODE C305 C405 1SS119 1SS119 11ES2-NTA2B 11ES2-NTA2B 11ES2-NTA2B 1-126-965-11 ELECT 1-126-965-11 ELECT 22uF 22uF 20% 20% 50V 50V < CONNECTOR > CN302 CN303 1-691-770-11 PLUG (MICRO CONNECTOR) 8P 1-691-768-11 PLUG (MICRO CONNECTOR) 6P < IC > < VARIABLE RESISTOR > IC700 8-759-111-68 IC uPC1237HA RV304 < COIL > L501 L601 1-223-936-11 RES, VAR, CARBON 120K/120K (ATTENUATOR) ************************************************************ 1-411-906-11 COIL, AIR-CORE 0.6uH 1-411-906-11 COIL, AIR-CORE 0.6uH MISCELLANEOUS ************** < TRANSISTOR > Q700 Q701 4 1-506-113-00 SHORT PLUG ! CNP1 1-777-185-11 CORD, POWER ! T1 1-431-827-11 TRANSFORMER, POWER ************************************************************ 8-729-119-76 TRANSISTOR 2SA1175-HFE 8-729-119-78 TRANSISTOR 2SC403SP-51 < RESISTOR > ACCESSORIES & PACKING MATERIALS ******************************** R528 R529 R628 R629 R700 1-249-162-11 1-247-750-11 1-249-162-11 1-247-750-11 1-249-437-11 CARBON CARBON CARBON CARBON CARBON 10 680 10 680 47K 5% 5% 5% 5% 5% 1/3W 1/2W 1/3W 1/2W 1/4W R701 R702 R703 R704 R705 1-249-429-11 1-249-429-11 1-259-476-11 1-249-433-11 1-247-883-00 CARBON CARBON CARBON CARBON CARBON 10K 10K 100K 22K 150K 5% 5% 5% 5% 5% 1/4W 1/4W 1/6W 1/4W 1/4W R706 R707 ! R708 R710 R711 1-249-431-11 1-249-429-11 1-217-493-00 1-247-747-11 1-247-747-11 CARBON CARBON FUSIBLE CARBON CARBON 15K 10K 100 470 470 5% 5% 5% 5% 5% 1/4W 1/4W 1W F 1/2W 1/2W 1-475-739-11 REMOTE COMMANDER (RM-S326) 3-864-461-11 MANUAL, INSTRUCTION (ENGLISH, FRENCH, SPANISH, PORTUGUESE) 3-864-461-21 MANUAL, INSTRUCTION (GERMAN, DUTCH, TURKISH, ITALIAN) 4-981-643-01 COVER, BATTERY (for RM-S326) The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. < RELAY > RY501 1-515-920-11 RELAY (24V) Sony Corporation 9-922-886-11 Home A&V Products Company – 36 – 98F0572-1 Printed in Japan © 1998. 6 Published by Quality Assurance Dept. (Shibaura)