Download SERVICE MANUAL

CDX-2250/3500
SERVICE MANUAL
US Model
Canadian Model
CDX-2250
E Model
CDX-3500
Photo: CDX-2250
SPECIFICATIONS
Model Name Using Similar Mechanism
CDX-2180
CD Drive Mechanism Type
MG-363X-121
Optical Pick-up Name
KSS-521A
FM/AM COMPACT DISC PLAYER
MICROFILM
–1–
SERVICE NOTE
CAUTION
Use of controls or adjustments or performance of procedures other than those specified herein may result in hazardous radiation exposure.
Notes on Chip Component Replacement
• Never reuse a disconnected chip component.
• Notice that the minus side of a tantalum capacitor may be damaged by heat.
NOTES ON HANDLING THE OPTICAL PICK-UP BLOCK OR
BASE UNIT
The laser diode in the optical pick-up block may suffer electrostatic
breakdown because of the potential difference generated by the
charged electrostatic load, etc. on clothing and the human body.
During repair, pay attention to electrostatic breakdown and also use
the procedure in the printed matter which is included in the repair
parts.
The flexible board is easily damaged and should be handled with
care.
NOTES ON LASER DIODE EMISSION CHECK
The laser beam on this model is concentrated so as to be focused on
the disc reflective surface by the objective lens in the optical pick-up
block. Therefore, when checking the laser diode emission, observe
from more than 30 cm away from the objective lens.
NOTES ON PICK-UP FLEXIBLE BOARD
The pick-up flexible board in this set is secured to the optical pick-up
with an adhesive tape. Once the tape is removed, an adhering force
becomes weak, and it cannot be reused.
Therefore, if the optical pick-up is replaced, replace also the pick-up
flexible board with a new one.
SAFETY-RELATED COMPONENT WARNING!!
COMPONENTS IDENTIFIED BY MARK ! OR DOTTED LINE
WITH MARK ! ON THE SCHEMATIC DIAGRAMS AND IN
THE PARTS LIST ARE CRITICAL TO SAFE OPERATION.
REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE
PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR
IN SUPPLEMENTS PUBLISHED BY SONY.
ATTENTION AU COMPOSANT AYANT RAPPORT
À LA SÉCURITÉ!!
LES COMPOSANTS IDENTIFIÉS PAR UNE MARQUE ! SUR LES
DIAGRAMMES SCHÉMATIQUES ET LA LISTE DES PIÈCES SONT
CRITIQUES POUR LA SÉCURITÉ DE FONCTIONNEMENT. NE
REMPLACER CES COMPOSANTS QUE PAR DES PIÈCES SONY
DONT LES NUMÉROS SONT DONNÉS DANS CE MANUEL OU
DANS LES SUPPLÉMENTS PUBLIÉS PAR SONY.
–2–
TABLE OF CONTENTS
1. GENERAL
Location of Controls ..................................................................
Getting Started ...........................................................................
CD Player ..................................................................................
Radio .........................................................................................
Other Functions .........................................................................
Additional Information ..............................................................
Connections ...............................................................................
4
4
5
5
6
6
8
2. DISASSEMBLY
2-1. Cover ASSY ........................................................................
2-2. Front Panel ASSY ...............................................................
2-3. Display Board .....................................................................
2-4. CD Mechanism Block .........................................................
2-5. Main Board .........................................................................
2-6. Heat Sink .............................................................................
2-7. Chassis (T) Sub ASSY ........................................................
2-8. Lever ASSY .........................................................................
2-9. Servo Board .........................................................................
2-10. Roller ASSY ........................................................................
2-11. Chassis (OP) (O/S) ASSY ...................................................
2-12. Optical Pick-up Block .........................................................
10
10
11
11
12
12
13
13
14
14
15
15
3. ELECTRICAL ADJUSTMENTS
Tuner Section ........................................................................... 16
CD Section .............................................................................. 18
4. DIAGRAMS
4-1.
4-2.
4-3.
4-4.
4-5.
4-6.
4-7.
4-8.
4-9.
IC Pin Description ...............................................................
Circuit Boards Location ......................................................
Printed Wiring Boards –CD Mechanism Section– ..............
Schematic Diagram –CD Mechanism Section– ..................
Printed Wiring Board –Display Section– ............................
Schematic Diagram –Display Section– ...............................
Printed Wiring Board –Main Section– ................................
Schematic Diagram –Main Section (1/2)– ..........................
Schematic Diagram –Main Section (2/2)– ..........................
19
21
23
25
27
29
31
33
35
5. EXPLODED VIEWS
5-1.
5-2.
5-3.
5-4.
5-5.
Chassis Section ...................................................................
Front Panel Section .............................................................
CD Mechanism Section (1) .................................................
CD Mechanism Section (2) .................................................
CD Mechanism Section (3) .................................................
39
40
41
42
43
6. ELECTRICAL PARTS LIST ........................................... 44
–3–
SECTION 1
GENERAL
–4–
This section extracted from US,
Canadian model’s instruction manual.
–5–
–6–
–7–
–8–
–9–
SECTION 2
DISASSEMBLY
Note : Follow the disassembly procedure in the numerical order given.
2-1. COVER ASSY
1 claw
4 cover assy
3 claws
2 claw
2-2. FRONT PANEL ASSY
1 claws
4 connector
5 front panel assy
2 claws
3 claw
– 10 –
2-3. DISPLAY BOARD
1 P 2x8
4 DISPLAY board
2 P 2x8
3 claws
2-4. CD MECHANISM BLOCK
7 PTT 2.6x6
2 PTT 2.6x6
8 bracket (M/D)
3 PTT 2.6x6
5 CD mechanism block
6 PTT 2.6x6
4 CNP701
1 PTT 2.6x6
– 11 –
2-5. MAIN BOARD
5 MAIN board
4 screws (+BTT)
3 screw (+BTT)
2 PTT 2.6x8
1 PTT 2.6x8
2-6. HEAT SINK
4 heat sink
1 PTT 2.6x8
2 PTT 2.6x10
3 PTT 2.6x8
– 12 –
2-7. CHASSIS (T) SUB ASSY
3 P 2x3
2 P 2x3
5 chassis (T) sub assy
1 Unsolder the
lead wires.
red
4 P 2x3
white
black
2-8. LEVER ASSY
5 guide (disc)
6 lever (R) assy
3 tension spring (LR)
7 lever (L) assy
1 PS 2x4
2 DISCIN board
4 claws
– 13 –
2-9. SERVO BOARD
6 PS 2x4
5 PS 2x4
2 CN2
1 CN3
3 P 2x3
7 SERVO board
4 loading motor assy
2-10. ROLLER ASSY
• When installing, take note of the positions
arm (roller) and washers. (Fig. 1)
washer
arm washer
washers
Fig. 1
3 roller assy
4 PS 2x3
2 arm (roller)
5 LOAD board
1 tension spring (RA)
– 14 –
arm
2-11. CHASSIS (OP) (O/S) ASSY
7 chassis (OP) (O/S) assy
8 compression spring (FL)
1 tension spring (angle)
9 compression spring (FL)
2 tension spring (KR1)
5 Fit lever (D) in the
direction of the arrow.
6 Turn loading ring in the
direction of the arrow.
3 damper (T)
4 damper (T)
2-12. OPTICAL PICK-UP BLOCK
1 P 2x3
2 sled motor assy
3 optical pick-up block
– 15 –
SECTION 3
ELECTRICAL ADJUSTMENTS
TUNER SECTION
FM SENS/IF Adjustment
Setting:
SOURCE button
: FMI
D-BASS switch
: OFF
Frequency Select switch (E model) : FM 200K
0 dB = 1 µV
Cautions during repair
When the tuner unit is defective, replace it by a new one because
its internal block is difficult to repair.
FM RF signal
generator
FM Center Adjustment
Setting:
SOURCE button
: FMI
D-BASS switch
: OFF
Frequency Select switch (E model) : FM 200K
FM RF signal
generator
dummy
antenna
dummy
antenna
50 Ω
4Ω
–
SPEAKER OUT
Procedure:
Adjust for a maximum reading on level meter.
set
50 Ω
+
set
50 Ω
antenna
terminal
50 Ω
level
meter
antenna
terminal
FEB1
Carrier frequency
Output lever
Mode
Modulation
87.5 MHz
: 97.9 MHz
: 60 dB (1 mV)
: mono
: 1 kHz, 75 kHz deviation (100%)
Adjustment Location: See page 17.
AM SENS Adjustment
Setting:
SOURCE n MODE button
: AM
D-BASS switch
: OFF
Frequency Select switch (E model) : AM 10K
digital
voltmeter
FM CENTER
OUT
IC1 pin #¶
(Both side
IC1 pin #¢
of R24.)
+
–
AM RF signal
generator
Procedure:
1. Adjust IFT4 on TU01 so that the reading on the digital voltmeter
becomes in 0 ± 30 mV.
2. Output an Fcenter 10 dB signal output from FM RF signal
generator so that the LINE OUT REAR jack is –20 dBs.
3. Change the FM RF signal generator frequency and check the
deviation of the frequency on + side and – side when the LINE
OUT REAR jack drops 3 dB. (Both + side and – side is approx.
50 kHz.)
4. Re-adjust IFT4 on TU01 when the difference deviation of the
frequency does more than 10 kHz.
dummy
antenna
30 Ω 15 pF
30 pF
Procedure:
Adjust for a maximum reading on level meter.
IFT1, 3
Adjustment Location: See page 17.
–3 dBs
(fc+10)
+
set
SPEAKER OUT
1,400 kHz
fc
4Ω
–
0 dBs
(fc–10)
level
meter
antenna
terminal
(kHz)
Adjustment Location: See page 17.
– 16 –
AM Auto Scan/Stop Level Adjustment
Setting:
SOURCE n MODE button
: AM
D-BASS switch
: OFF
Frequency Select switch (E model) : AM 10K
AM RF signal
generator
dummy
antenna
digital
voltmeter
4Ω
Procedure:
1. Adjust IFT3 on TU01 so that the reading on the digital
voltmeter is 1.5 ± 0.2 V.
+
set
30 pF
–
Carrier frequency : 1000 kHz
30% amplitude
modulation by
1 kHz signal
output level
: 33 dB (44.7 µV)
–
level
meter
antenna
terminal
30 Ω 15 pF
+
S-METER OUT
Adjustment Location: tuner unit (TU01)
SPEAKER OUT
Adjustment Location: tuner unit (TU01)
– tuner unit (TU01) (component side) –
AM AUTO
SCAN/STOP
LEVEL ADJ
IFT3
AM SENS
ADJ
IFT3
IFT1
IFT4
FM CENTER
ADJ
FEB1
FM SENS/IF
ADJ
– tuner unit (TU01) (conductor side) –
‘
IC1
R24
S-METER
OUT
– 17 –
’
FM CENTER
OUT
CD SECTION
Note:
1. CD Block basically constructed to operate without adjustment.
Therefore, check each item in order given.
2. Use YEDS-18 disc (3-702-101-01) unless otherwise indicated.
3. Use the oscilloscope with more than 10 MΩ impedance.
4. Clean an objective lens by an applicator with neutral detergent
when the signal level is low than specified value with the following
checks.
Focus Bias Adjustment
Setting: This adjustment is performed with the set placed
horizontally.
oscilloscope
SERVO board
TP (RF)
TP (RF. GND)
Focus Gain Adjustment (Coarse adjustment)
This adjustment is not required unless the following parts are replaced:
• Optical pick-up
• RV4
Procedure:
1. Set RV4 to the standard position. (mechanical center)
2. Check whether operation noise (while noise type) caused by
the 2-axis device (lens section of the optical pick-up) is
abnormally loud.
If the operation noise is too loud, turn RV4 slightly counterclockwise.
• If the gain is too low:
Focus does not function and no music is selected.
• If the gain is too high:
Noise caused by scratches and dust is heard and the operation
becomes unstable.
Adjustment Location: servo board
+
–
Adjustment Location: servo board (component side)
Procedure:
1. Connect an oscilloscope between TP (RF) and TP (RF. GND)
on the SERVO board.
2. Connect the power supply.
3. Push the RESET button (S881) on the DISPLAY board.
4. Insert the disc (YEDS-18) and playback.
5. Adjust RV1 so that the oscilloscope waveform is clear and check
RF signal level is correct or not.
Note: Clear RF signal waveform means that the sharp “≈” can be
clearly distinguished at the center of the waveform.
FOCUS GAIN ADJ
RV4
IC3
CN2
RF signal waveform
VOLT/DIV: 200 mV
TIME/DIV: 500 nS
TP
(RF. GND)
IC1
CN1
IC2
level: 1.0 – 1.5 Vp-p
• When observing the eye pattern, set the oscilloscope to AC range
and raise the vertical sensitivity so that it may be easily seen.
TP
(RF)
CN3
Adjustment Location: servo board
RV1
FOCUS BIAS ADJ
– 18 –
SECTION 4
DIAGRAMS
4-1. IC PIN DESCRIPTION
• IC801 µPD17705GC-537-3B9 (SYSTEM CONTROL)
Pin No.
Pin Name
I/O
1
SIRCS
I
SIRCS input (A/D)
Pin Description
2
3
IN-SW
D-SW
I
I
CD mechanism position detection
CD mechanism position detection
4
5
SELF-SW
L-SW
I
I
CD mechanism position detection
LIMIT switch
6
7
LM-EJ
LM-LOD
O
O
Loading motor control (Eject direction)
Loading motor control (Loading direction)
8
9
AMP/ANT-ON
MONO
O
O
Power control for amplifier.
Force MONO output
10
11
SD
BAND-SW
I
I
SD signal input
Initialize switch input terminal
12
13
AREA1-SW
AREA2-SW
I
I
Initialize switch input terminal
Initialize switch input terminal
14, 15
16
RE1, 2
SEEK
I
O
Rotary encoder input 1, 2
SEEK output
17
18
CD-ON
FM-ON
I/O
I/O
Servo drive power
FM select output
19
20
TU-ON
NC
I/O
—
AM select output
Not used.
21
22
GND3
KEYIN3
—
I
Ground
Not used (Connect to ground)
23, 24
25
26
KEYIN2, 1
ROT-IN
S-METER
I
I
I
A/D key input 2, 1
Rotary commander input
FM and AM common signal meter A/D conversion input
27
28
TEST-SW
AM-IFC
I
I
TEST mode select input
AM center frequency input
29
30
FM-IFC
VDD2
I
—
FM center frequency input
Power supply (+5 V)
31
32
VCOH-FM
VCOL-AM
I
I
33
34
GND2
NC
—
—
Ground
Not used.
35
36
EO1-PDOUT
TESTO
O
—
Error out output
Connect to ground
37
38
AM-ON(TU-ON)
FM-ON(FM/AM)
O
O
AM power output (AM select)
FM power output (FM select)
39
40
LCL/DX
BEEP
O
O
LOCAL/DX select (“H” : LOCAL, “L” : DX)
BEEP output
41
42
ACC-IN
SCOR
I
I
Accessory input
SUBQ data read request
43
44
MUTE
AMP-MUTE
O
O
System mute output
Power amplifier mute output
45
46
TEL-MUTE
NC
O
—
Telephone mute output
Fixed at “H” in this set.
47
48
VOL-CE
VOL-CLK
O
O
Electric volume chip select
Electric volume serial clock
49
50
VOL-DATA
EMPHO
O
O
Electric volume serial data
De-emphasis control output
51
52
PW-ON
MD-ON
O
O
System power control
Loading motor power
53
CD-ON
O
Servo drive power
Local oscillation frequency input (FM)
Local oscillation frequency input (AM)
– 19 –
Pin No.
54
Pin Name
ILL-ON
I/O
O
Pin Description
55
56
C.ALARM
NC
I
I
57
58
NC
LCD-CE
—
O
59
60
EZ-SEL
SENS
I
I
SHIFT + input
Information input from servo IC.
61
62
FOK
LD-ON
I
O
Focus OK input
Laser diode control
63
64
NC
[IN] ST/MONO
—
I/O
65
[OUT] MONO
LCD-CKO
O
LCD driver serial clock output
66
67
LCD-So
INH
O
O
LCD driver serial data output
INHbit output
68
69
SQ-CKo
CD-RST
O
O
Q data read serial clock output
Servo IC/DAC reset output
70
71
SQ-SI
CD-SO
I
O
Q data input
Serial data output to servo IC.
72
73
CD-LAT
CD-CKO
O
O
Data latch output to servo IC.
Serial clock output to servo IC.
74
75
VREF
GND1
—
—
Not used.
Ground
76
77
78
X-OUT
X-IN
BU-IN
—
I
I
Crystal oscillator connection (4.5 MHz)
Crystal oscillator connection (4.5 MHz)
Back-up detection
79
80
VDD1
RESET
—
I
Power supply (+5 V)
RESET input
Illumination output
Caution alarm select input (Used/Not used)
Not used (Connect to ground)
Fixed at “H” in this set.
LCD drive chip select output
Not used. (Connect to ground)
Used for both STEREO indicator display input and force MONO output. (FM)
– 20 –
4-2. CIRCUIT BOARDS LOCATION
• Waveforms
(MODE:PLAY)
1
0V
DISCIN board
SUB board
Approx. 620mVp-p
TU01
tuner assy
IC2
LIMIT board
1
(FEO)
2
1.2Vp-p
IC2
#¡
(RFO)
3
0V
Approx. 200mVp-p
IC2
$™
(TEO)
4
2.6Vp-p
DISPLAY board
MAIN board
7.6µsec
IC1
LOAD board
SERVO board
3
(MDP)
5
5.8Vp-p
22.7µsec
IC1
@º
(LRCK)
6
5.7Vp-p
474nsec
IC1
@™
(BCK)
7
3.2Vp-p
16.89MHz
IC1
#¢
(XTAI)
Note on Schematic Diagram:
• All capacitors are in µF unless otherwise noted. pF: µµF
50 WV or less are not indicated except for electrolytics
and tantalums.
• All resistors are in Ω and 1/4 W or less unless otherwise
specified.
Note: The components identified by mark ! or dotted line
with mark ! are critical for safety.
Replace only with part number specified.
• U : B+ Line.
• H : adjustment for repair.
• Power voltage is dc 14.4V and fed with regulated dc power
supply from ACC and BATT cords.
• Voltage and waveforms are dc with respect to ground
under no-signal conditions.
no mark : CD PLAY
: Impossible to measure
∗
• Voltages are taken with a VOM (Input impedance 10 MΩ).
Voltage variations may be noted due to normal production
tolerances.
• Waveforms are taken with a oscilloscope.
Voltage variations may be noted due to normal production
tolerances.
• Circled numbers refer to waveforms.
• Signal path.
J : CD
– 21 –
– 22 –
CDX-2250/3500
4-3. PRINTED WIRING BOARDS — CD MECHANISM SECTION —
• Semiconductor
Location
Ref. No. Location
IC1
D-2
IC2
E-5
IC3
B-2
Q1
Q2
F-6
F-6
Note:
• X : parts extracted from the component side.
• Y : parts extracted from the conductor side.
• b : Pattern from the side which enables seeing.
– 23 –
– 24 –
CDX-2250/3500
4-4. SCHEMATIC DIAGRAM — CD MECHANISM SECTION — • Refer to page 22 for Waveforms and Note and page 37 for IC Block Diagrams.
(Page
33)
– 25 –
– 26 –
CDX-2250/3500
4-5. PRINTED WIRING BOARD — DISPLAY SECTION —
• Semiconductor Location
Ref. No. Location
Ref. No.
(D551)
B-10
D566
(D552)
B-9
D567
(D554)
B-10
D568
D561
B-12
D569
D562
A-13
D570
D563
B-13
D571
D564
C-5
D572
D565
C-4
D573
(
Location
A-4
C-2
C-9
C-8
C-7
C-12
C-11
C-3
Ref. No.
D574
D575
D576
D577
D578
Location
C-2
B-3
A-2
B-1
A-1
(IC551)
B-7
Note:
®
•
: Through hole.
• b : Pattern from the side which enables seeing.
(The other layer’s patterns are not indicated.)
Caution:
Pattern face side:
(Side B)
Parts face side:
(Side A)
Parts on the pattern face side seen from the
pattern face are indicated.
Parts on the parts face side seen from the
parts face are indicated.
) : SIDE B
– 27 –
– 28 –
CDX-2250/3500
4-6. SCHEMATIC DIAGRAM — DISPLAY SECTION —
(Page 36)
Note:
• All capacitors are in µF unless otherwise noted. pF: µµF
50 WV or less are not indicated except for electrolytics
and tantalums.
• All resistors are in Ω and 1/4 W or less unless otherwise
specified.
• U : B+ Line.
• Power voltage is dc 14.4V and fed with regulated dc power
supply from ACC and BATT cords.
– 29 –
• C : panel designation.
• Voltage is dc with respect to ground under no-signal
(detuned) condition.
no mark : FM
• Voltages are taken with a VOM (Input impedance 10 MΩ).
Voltage variations may be noted due to normal production
tolerances.
– 30 –
CDX-2250/3500
4-7. PRINTED WIRING BOARD — MAIN SECTION —
• Semiconductor Location
Ref. No. Location
Ref. No.
D401
B-5
Q102
D402
B-1
Q201
D604
E-6
Q202
D701
D-2
Q401
D811
B-3
Q402
D812
B-2
Q601
D901
C-1
Q602
D902
B-1
Q605
D903
D-1
Q606
D904
E-1
Q801
D905
E-1
Q901
D906
B-1
Q902
D907
B-1
Q904
D908
B-2
Q905
D910
B-4
Q906
D911
B-1
Q907
D914
B-2
Q908
D916
A-3
Q909
D917
B-4
Q910
D918
A-3
Q911
Q912
IC401
C-4
Q913
IC402
A-4
Q915
IC701
C-2
Q916
IC801
E-4
Q917
Q918
Q101
B-5
Location
B-5
B-5
B-5
B-5
B-5
D-6
D-6
C-6
C-6
D-3
D-1
C-1
D-1
C-1
D-1
C-1
B-2
B-3
E-1
E-2
E-1
E-1
B-1
C-1
E-1
D-1
Note:
• X : parts extracted from the component side.
¢
•
: internal component.
• b : Pattern from the side which enables seeing.
• Abbreviation
CND : Canadian model.
– 31 –
– 32 –
CDX-2250/3500
4-8. SCHEMATIC DIAGRAM — MAIN SECTION (1/2) —
(Page 26)
Note:
• All capacitors are in µF unless otherwise noted. pF: µµF
50 WV or less are not indicated except for electrolytics
and tantalums.
• All resistors are in Ω and 1/4 W or less unless otherwise
specified.
¢
•
: internal component.
• C : panel designation.
• U : B+ Line.
• Power voltage is dc 14.4V and fed with regulated dc power
supply from ACC and BATT cords.
• Voltage is dc with respect to ground under no-signal
(detuned) condition.
no mark : FM
(
) : AM
<
> : CD PLAY
: Impossible to measure
∗
• Voltages are taken with a VOM (Input impedance 10 MΩ).
Voltage variations may be noted due to normal production
tolerances.
• Signal path.
F : FM
f : AM
J : CD
• Abbreviation
CND : Canadian model.
– 33 –
– 34 –
CDX-2250/3500
4-8. SCHEMATIC DIAGRAM — MAIN SECTION (2/2) —
• Refer to page 37 for IC Block Diagrams.
(Page 29)
– 35 –
– 36 –
• IC Block Diagrams
LVRIN
LCOM
LT1
LT2
LT3
LTOUT
LSIN
NC
NC
LSB1
LSB2
IC401 LC75374E
33
32
31 30
29
28 27 26 25 24
23
22 LFIN
+
–
+
–
–
+
34
35
36
37
38
+
–
21 LFOUT
+
–
20 LROUT
–
+
LSELO
L4
L3
L2
L1
–
+
+
–
19 VREF
VDD 39
–
+
R1
R2
R3
R4
RSELO
–
+
18 CE
17 DI
16 CL
15
VSS
14 RROUT
–
+
13 RFOUT
CONTROL
–
+
40
41
42
43
44
DECODER
SHIFT
REGISTER
LATCH
+
–
–
+
+
–
–
+
6 7 8 9 10
11
RTOUT
RSIN
NC
NC
RSB1
RSB2
5
RT3
RCOM
RVRIN
3 4
RT1
RT2
12 RFIN
2
1
IC402 TDA7385
TAB
PW-GND
OUT2–
ST-BY
OUT2+
Vcc1
OUT1–
PW-GND1
OUT1+
SVR
IN1
IN2
S-GND
IN4
IN3
AC-GND
OUT3+
PW-GND3
OUT3–
Vcc2
OUT4+
MUTE
OUT4–
PW-GND4
DIAGNOSTICS OUT
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25
OP IN –
OP IN +
VREF
CH3
CH3-IN
CH2
CH2-IN
VCC
CH1
CH1-IN
CH1 +
CH1 –
CH2 +
CH2 –
IC3 BA6796FP-T1
28
27
26
25
24
23
22
21
20
19
18
17
16
15
LEVEL
SHIFT
VCC
LEVEL
SHIFT
DRIVE
BUFFER
DRIVE
BUFFER
DRIVE
BUFFER
DRIVE
BUFFER
LEVEL
SHIFT
THERMAL
SHUT
DOWN
14
CH3 –
4
5
6
7
8
9
10
CH5 –
13
3
GND
12
2
TRAY
11
1
REV
DRIVE
BUFFER
FWD
DRIVE
BUFFER
CTL2
DRIVE
BUFFER
CTL1
DRIVE
BUFFER
CH4
DRIVE
BUFFER
CH4-IN
REV
OPOUT
FWD
CH3 +
V/I
CTL2
CH4 +
LOGIC
CTL1
COM
LEVEL
SHIFT
– 37 –
PHD 1
PHD
LD
RF M
RF O
RF I
CP
CB
CC1
36
35
34
33
32
31
30
29
28
27 26 25
FOK
CC2
PHD 2
IC2 CXA1782BQ
LEVEL S
FOK
APC
MIRR
RF IV AMP1
IIL
24
SENS
TTL
23
C.OUT
22
XRST
21
DATA
20
XLT
19
CLK
18
VCC
17
ISET
16
SL O
15
SL M
14
SL P
13
TA O
DFCT
TTL
RF IV AMP2
TTL
FE BIAS 37
IIL DATA REGISTER
INPUT SHIFT REGISTER
FE AMP
ADDRESS DECODER
F
IIL
IIL
OUTPUT DECODER
38
TOG1-3
BAL1-3
F IV AMP
E
39
EI
40
FS1-4
TG1-2
TM1-7
PS1-4
FZC COMP
E IV AMP
BAL 3
BAL2
BAL1
TE AMP
HPF COMP
VEE
TRACKING
PHASE
COMPENSATION
LPF COMP
ISET
41
TM6
TED 42
TOG3
TOG2
TOG1
TG1
TM5
TM4
TEI
TZC
TM3
44
ATSC 45
46
FCS PHASE
COMPENSATION
TZC COMP
LPFI 43
TM2
DFCT
WINDOW COMP
FS1
TM1
TM7
FS2
ATSC
TDFCT 47
F SET
6
7
8 9
10
11
12
TG2
FSET
TA M
– 38 –
TGU
FDFCT
5
SRCH
FEI
4
FE O
3
FE M
2
FLB
1
FGD
FS4
48
FEO
VC
TG2
DFCT
SECTION 5
EXPLODED VIEWS
NOTE:
• -XX, -X mean standardized parts, so they may have
some difference from the original one.
• Items marked “*” are not stocked since they are
seldom required for routine service. Some delay
should be anticipated when ordering these items.
• Color Indication of Appearance Parts Example:
KNOB, BALANCE (WHITE) . . . . (RED)
Â
Â
Parts color Cabinets color
The components identified by
mark ! or dotted line with mark
! are critical for safety.
Replace only with part number
specified.
• The mechanical parts with no reference number in
the exploded views are not supplied.
• Hardware (# mark) list and accessories and packing materials are given in the last of this parts list.
Les composants identifiés par une
marque ! sont critiques pour la
sécurité.
Ne les remplacer que par une
piéce portant le numéro spécifié.
5-1. CHASSIS SECTION
4
#1
MG-363X-121
3
#1
11
1
#2
A
#2
5
10
#2
#3
5
8
#2
#2
F901
TU01
#1
7
9
B
6
A
2
#1
B
Ref. No.
Part No.
Description
* 1
* 2
3
* 4
5
3-030-925-01
3-030-876-01
1-769-786-81
3-030-927-01
3-922-535-11
COVER
CHASSIS
CORD (WITH CONNECTOR) (POWER)
BRACKET (MD)
SCREW (+BTT)
* 6
* 6
A-3294-553-A MAIN BOARD, COMPLETE (CDX-2250)
A-3294-635-A MAIN BOARD, COMPLETE (CDX-3500)
Remark
Ref. No.
Part No.
* 7
* 8
* 9
3-030-849-01 HEAT SINK (T)
3-019-565-01 BRACKET (IC)
3-030-850-01 HEAT SINK (REG)
* 10
F901
TU01
3-024-285-01 CUSHION (RUBBER)
1-532-877-11 FUSE (BLADE TYPE) (AUTO FUSE) 10A
A-3301-697-A TUNER ASSY
– 39 –
Description
Remark
5-2. FRONT PANEL SECTION
#4
65
59
#4
58
C
57
#4
64
63
LCD551
66
62
60
61
54
C
51
53
56
52
Ref. No.
Part No.
Description
51
51
52
52
53
X-3376-779-1
X-3377-101-1
3-019-544-03
3-019-544-23
3-019-542-01
54
55
56
57
58
3-019-550-01
3-019-552-01
3-030-873-11
3-025-315-02
3-019-547-01
55
Remark
Ref. No.
Part No.
Description
PANEL (S) ASSY, FRONT (CDX-2250)
PANEL (S) ASSY, FRONT (CDX-3500)
KNOB (SEEK/AMS)(CDX-2250)
KNOB (SEEK/AMS)(CDX-3500)
BUTTON (RESET)
59
60
* 61
* 62
* 63
3-019-548-01
3-019-543-01
X-3376-745-1
3-019-557-01
3-019-561-01
RING
KNOB (D-BASS)
HOLDER ASSY, LCD
PLATE (LCD), GROUND
SHEET, LCD COLOR
BUTTON (MODE/SOUND)
BUTTON (1-6)
BUTTON (CD EJECT)
BUTTON (SOURCE)
KNOB (VOL)
64
* 65
66
LCD551
3-019-558-01
A-3294-555-A
1-783-268-11
1-803-439-21
SHEET (D) (LCD)
DISPLAY BOARD, COMPLETE (CDX-2250)
CABLE, FLAT
DISPLAY PANEL, LIQUID CRYSTAL
– 40 –
Remark
5-3. CD MECHANISM SECTION (1) (MG-363X-121)
#8
102
#8
104
111
103
112
107
#8
109
111
101
112
105
#7
106
108
113
E
114
M903
115
E
110
#9
#7
116
#7
Ref. No.
Part No.
Description
* 101
* 102
103
104
105
1-659-836-11
A-3291-816-B
3-931-909-01
X-3371-501-1
3-338-737-01
DISCIN BOARD
CHASSIS (T) SUB ASSY
SPRING (LR), TENSION
LEVER (L) ASSY
SCREW (2X3), + PS
* 106
107
108
109
1-659-837-11
X-3371-502-1
A-3301-203-A
3-931-908-01
LOAD BOARD
LEVER (R) ASSY
ROLLER ASSY
GUIDE (DISC)
Remark
Ref. No.
110
#8
Part No.
Description
3-931-902-04 ARM (ROLLER)
111
112
* 113
114
* 115
3-936-756-01
3-321-393-01
3-939-139-01
3-931-916-01
A-3309-227-A
* 116
M903
3-007-530-01 BRACKET (MOTOR)
A-3291-676-A MOTOR SUB ASSY, LOADING
– 41 –
ROLLER (D)
WASHER, STOPPER
SPACER
SPRING (RA), TENSION
SERVO BOARD, COMPLETE
Remark
5-4. CD MECHANISM SECTION (2) (MG-363X-121)
154
151
#9
155
156
157
157
158
F
160
162
165
160
163
164
153
161
F
159
152
152
152
Ref. No.
Part No.
Description
151
152
153
* 154
155
3-931-893-01
3-931-897-01
3-931-879-02
3-913-404-11
3-931-894-01
ARM, CHUCKING
DAMPER (T)
LEVER (D)
RETAINER (DISC)
BRACKET (CP)
156
157
158
3-931-895-01 SPRING (CH), TENSION
3-931-898-01 SPRING (FL), COMPRESSION
3-032-483-02 SPRING (KF1), TENSION
Remark
Ref. No.
Part No.
* 159
160
A-3277-802-C CHASSIS (M) COMPLETE ASSY
3-014-727-01 WHEEL (LW), WORM
161
162
163
164
165
– 42 –
3-931-881-01
3-931-882-02
3-007-537-11
3-032-484-01
3-018-272-01
Description
LEVER (LOCK)
GEAR (MDL)
WHEEL (U), WORM
SPRING (KR1), TENSION
WASHER
Remark
5-5. CD MECHANISM SECTION (3) (MG-363X-121)
201
#6
M901
207
202
#9
M902
203
208
205
#5
206
209
210
#8
204
213
211
212
#8
The components identified by
mark ! or dotted line with mark
! are critical for safety.
Replace only with part number
specified.
Ref. No.
Part No.
Description
* 201
202
203
204
* 205
X-3374-022-1
3-931-829-01
X-3371-504-1
3-931-832-01
1-659-835-12
CHASSIS (OP) (O/S) ASSY
SPRING (SL), PLATE
BASE (DRIVING) ASSY
GEAR (SL MIDWAY)
LIMIT BOARD
206
207
* 208
3-338-737-01 SCREW (2X3), + PS
1-659-880-11 MOTOR FLEXIBLE BOARD
1-659-834-11 SUB BOARD
Remark
Les composants identifiés par une
marque ! sont critiques pour la
sécurité.
Ne les remplacer que par une
piéce portant le numéro spécifié.
Ref. No.
Part No.
209
! 210
3-909-607-01 SCREW
8-820-010-06 PICK-UP, OPTICAL KSS-521A/Q-NP
211
212
213
M901
M902
– 43 –
3-931-834-01
1-659-881-11
A-3291-669-A
X-3371-664-2
A-3291-674-A
Description
SPRING (FEED), PLATE
PICKUP FLEXIBLE BOARD
SHAFT (FEED) ASSY
MOTOR ASSY (SPINDLE)
MOTOR ASSY, SLED
Remark
DISCIN
SECTION 6
ELECTRICAL PARTS LIST
DISPLAY
Note:
The components identified by
mark ! or dotted line with mark
! are critical for safety.
Replace only with part number
specified.
Les composants identifiés par une
marque ! sont critiques pour la
sécurité.
Ne les remplacer que par une
piéce portant le numéro spécifié.
When indicating parts by reference
number, please include the board
name.
Ref. No.
Part No.
*
1-659-836-11 DISCIN BOARD
************
• Due to standardization, replacements in the parts list
may be different from the parts specified in the
diagrams or the components used on the set.
• -XX, -X mean standardized parts, so they may have
some difference from the original one.
• Items marked “*” are not stocked since they are
seldom required for routine service. Some delay
should be anticipated when ordering these items.
• RESISTORS
All resistors are in ohms
METAL: Metal-film resistor
METAL OXIDE: Metal Oxide-film resistor
F : nonflammable
Description
Remark
Ref. No.
Part No.
• SEMICONDUCTORS
In each case, u: µ , for example:
uA...: µ A..., uPA...: µ PA..., uPB...: µ PB...,
uPC...: µ PC..., uPD...: µ PD...
• CAPACITORS
uF : µ F
• COILS
uH : µ H
• Abbreviation
CND : Canadian model
Description
Remark
D577
8-719-067-77 DIODE SML-010PT-T86
D578
8-719-067-77 DIODE SML-010PT-T86 (MODE)
< SWITCH >
< IC >
SW1
SW2
1-572-288-21 SWITCH, PUSH
1-572-288-21 SWITCH, PUSH
IC551
8-759-369-90 IC LC75822ED
< JUMPER RESISTOR >
**************************************************************
*
A-3294-555-A DISPLAY BOARD, COMPLETE (CDX-2250)
************************
*
A-3294-636-A DISPLAY BOARD, COMPLETE (CDX-3500)
************************
3-019-558-01
3-019-557-01
3-019-561-01
X-3376-745-1
*
*
*
SHEET (D) (LCD)
PLATE (LCD), GROUND
SHEET, LCD COLOR
HOLDER ASSY, LCD
JR512
JR513
JR514
JR515
JR516
1-216-296-00
1-216-296-00
1-216-296-00
1-216-296-00
1-216-296-00
SHORT
SHORT
SHORT
SHORT
SHORT
0
0
0
0
0
JR517
JR518
JR519
JR520
JR521
1-216-296-00
1-216-295-00
1-216-296-00
1-216-296-00
1-216-296-00
SHORT
SHORT
SHORT
SHORT
SHORT
0
0
0
0
0
JR522
JR561
1-216-296-00 SHORT
1-216-295-00 SHORT
0
0
< CAPACITOR >
C551
C552
C553
1-163-137-00 CERAMIC CHIP
1-163-038-00 CERAMIC CHIP
1-163-117-00 CERAMIC CHIP
680PF
0.1uF
100PF
5%
5%
< CONNECTOR >
50V
25V
50V
< LIQUID CRYSTAL DISPLAY >
LCD551 1-803-439-21 DISPLAY PANEL, LIQUID CRYSTAL
* CNP552 1-779-130-11 PIN, CONNECTOR 1P
< DIODE >
D551
D552
D554
D561
D562
8-719-073-15
8-719-067-70
8-719-068-68
8-719-067-77
8-719-067-77
DIODE
DIODE
DIODE
DIODE
DIODE
SDZ5V1
SDZ6V2-6.2
SDZ6V2WA
SML-010PT-T86 (SENS)
SML-010PT-T86 (DSPL)
D563
D564
D565
D566
D567
8-719-067-77
8-719-067-77
8-719-067-77
8-719-067-77
8-719-067-77
DIODE
DIODE
DIODE
DIODE
DIODE
SML-010PT-T86 (6)
SML-010PT-T86 (1)
SML-010PT-T86 (OFF)
SML-010PT-T86 (SOUND)
SML-010PT-T86 (SOURCE)
D568
D569
D570
D571
D572
8-719-067-77
8-719-067-77
8-719-067-77
8-719-067-77
8-719-067-77
DIODE
DIODE
DIODE
DIODE
DIODE
SML-010PT-T86 (4)
SML-010PT-T86 (3)
SML-010PT-T86 (2)
SML-010PT-T86 (6)
SML-010PT-T86 (5)
D573
D574
D575
D576
8-719-067-77
8-719-067-77
8-719-067-77
8-719-067-77
DIODE
DIODE
DIODE
DIODE
SML-010PT-T86
SML-010PT-T86
SML-010PT-T86
SML-010PT-T86
< PILOT LAMP >
PL551
PL552
1-517-665-21 LAMP PILOT
1-517-665-21 LAMP PILOT
< RESISTOR >
R551
R552
R553
R554
R555
1-216-057-00
1-216-057-00
1-216-206-00
1-216-057-00
1-216-210-00
METAL CHIP
METAL CHIP
RES,CHIP
METAL CHIP
RES,CHIP
2.2K
2.2K
2.2K
2.2K
3.3K
5%
5%
5%
5%
5%
1/10W
1/10W
1/8W
1/10W
1/8W
R556
R557
R558
R559
R561
1-216-065-00
1-216-218-00
1-216-073-00
1-216-226-00
1-216-057-00
RES,CHIP
RES,CHIP
METAL CHIP
RES,CHIP
METAL CHIP
4.7K
6.8K
10K
15K
2.2K
5%
5%
5%
5%
5%
1/10W
1/8W
1/10W
1/8W
1/10W
R562
R563
R564
R565
R566
1-216-057-00
1-216-057-00
1-216-057-00
1-216-061-00
1-216-065-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
RES,CHIP
2.2K
2.2K
2.2K
3.3K
4.7K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R567
1-216-069-00 METAL CHIP
6.8K
5%
1/10W
– 44 –
DISPLAY
Ref. No.
LIMIT
LOAD
MAIN
Part No.
Description
Remark
Ref. No.
Part No.
R568
R569
R581
R582
1-216-073-00
1-216-077-00
1-216-090-00
1-216-045-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
15K
51K
680
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
*
A-3294-553-A MAIN BOARD, COMPLETE (CDX-2250)
*********************
*
A-3294-635-A MAIN BOARD, COMPLETE (CDX-3500)
*********************
R584
R585
R586
R587
R588
1-216-189-00
1-216-186-00
1-216-189-00
1-216-186-00
1-216-186-00
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
430
330
430
330
330
5%
5%
5%
5%
5%
1/8W
1/8W
1/8W
1/8W
1/8W
R591
R592
R593
R594
R595
1-216-183-00
1-216-183-00
1-216-183-00
1-216-183-00
1-216-183-00
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
240
240
240
240
240
5%
5%
5%
5%
5%
1/8W
1/8W
1/8W
1/8W
1/8W
R596
R597
R598
1-216-183-00 RES,CHIP
1-216-206-00 RES,CHIP
1-216-057-00 METAL CHIP
240
2.2K
2.2K
5%
5%
5%
1/8W
1/8W
1/10W
SCREW +PTT 2.6X6 (S)
SCREW +PTT 2.6X8 (S)
SCREW +PTT 2.6X10 (S)
BRACKET (IC)
*
*
3-030-849-01 HEAT SINK (T)
3-030-850-01 HEAT SINK (REG)
C101
C102
C103
C104
1-163-007-11
1-162-587-11
1-164-346-11
1-164-489-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
680PF
0.039uF
1uF
0.22uF
10%
10%
50V
25V
16V
10%
16V
(CDX-3500)
10%
16V
(CDX-2250)
C104
1-164-492-11 CERAMIC CHIP
0.15uF
C105
C106
C107
C108
C109
1-124-233-11
1-124-233-11
1-163-009-11
1-163-009-11
1-163-038-00
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
10uF
10uF
0.001uF
0.001uF
0.1uF
20%
20%
10%
10%
16V
16V
50V
50V
25V
C110
C111
C112
C113
C114
1-163-038-00
1-164-346-11
1-164-346-11
1-164-182-11
1-163-037-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
1uF
1uF
0.0033uF 10%
0.022uF 10%
25V
16V
16V
50V
25V
C115
C116
C117
C118
C201
1-124-233-11
1-164-492-11
1-164-492-11
1-124-233-11
1-163-007-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
10uF
0.15uF
0.15uF
10uF
680PF
20%
10%
10%
20%
10%
16V
16V
16V
16V
50V
C202
C203
C205
C206
C207
1-162-587-11
1-164-346-11
1-124-233-11
1-124-233-11
1-163-009-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP
0.039uF
1uF
10uF
10uF
0.001uF
10%
25V
16V
16V
16V
50V
C208
C209
C210
C211
C212
1-163-009-11
1-163-038-00
1-163-038-00
1-164-346-11
1-164-346-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.001uF
0.1uF
0.1uF
1uF
1uF
10%
50V
25V
25V
16V
16V
C213
C214
C215
C216
C217
1-164-182-11
1-163-037-11
1-124-233-11
1-164-492-11
1-164-492-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
0.0033uF
0.022uF
10uF
0.15uF
0.15uF
10%
10%
20%
10%
10%
50V
25V
16V
16V
16V
C218
C401
C405
C407
C408
1-124-233-11
1-124-233-11
1-126-514-11
1-124-259-11
1-164-346-11
ELECT
ELECT
ELECT
ELECT
CERAMIC CHIP
10uF
10uF
22uF
4.7uF
1uF
20%
20%
20%
20%
16V
16V
16V
16V
16V
C409
C410
1-163-109-00 CERAMIC CHIP
1-104-663-11 ELECT
47PF
33uF
5%
20%
1-475-014-11 ENCODER, ROTARY
< SWITCH >
S551
S552
S553
S554
S555
1-572-704-31
1-572-704-31
1-572-704-31
1-572-704-31
1-572-704-31
S556
S557
S558
S561
S562
1-771-290-11 SWITCH, SLIDE
(SEEK/AMS = 0 -/+ ) +)
1-572-704-31 SWITCH, KEY BOARD (1)
1-572-704-31 SWITCH, KEY BOARD (2)
1-572-704-31 SWITCH, KEY BOARD (OFF)
1-572-704-31 SWITCH, KEY BOARD (SOURCE)
S563
S564
S565
S566
S567
1-572-704-31
1-572-704-31
1-572-704-31
1-572-704-31
1-762-937-11
S581
1-572-704-31 SWITCH, KEY BOARD (RESET)
SWITCH, KEY BOARD (6)
SWITCH, KEY BOARD (DSPL)
SWITCH, KEY BOARD (SENS)
SWITCH, KEY BOARD (SOUND)
SWITCH, KEY BOARD (MODE)
SWITCH, KEY BOARD (3)
SWITCH, KEY BOARD (4)
SWITCH, KEY BOARD (5)
SWITCH, KEY BOARD (6)
SWITCH, ROTARY (D-BASS)
**************************************************************
1-659-835-12 LIMIT BOARD
***********
*
*
7-685-792-09
7-685-793-09
7-685-794-09
3-019-565-01
Remark
< CAPACITOR >
< ROTARY ENCODER >
RE551
Description
20%
20%
10%
< SWITCH >
SW3
1-572-688-11 SWITCH, PUSH (1 KEY)
**************************************************************
1-659-837-11 LOAD BOARD
**********
*
< SWITCH >
SW4
1-572-288-21 SWITCH, PUSH
**************************************************************
– 45 –
50V
25V
(CDX-2250)
MAIN
Ref. No.
Part No.
Description
Remark
C411
C412
C413
1-124-465-00 ELECT
1-164-346-11 CERAMIC CHIP
1-124-242-00 ELECT
0.47uF
1uF
33uF
20%
20%
50V
16V
25V
C414
C501
C601
C602
C603
1-164-346-11
1-164-004-11
1-163-235-11
1-164-161-11
1-164-004-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
1uF
0.1uF
22PF
0.0022uF
0.1uF
10%
5%
10%
10%
16V
25V
50V
100V
25V
C604
C605
C606
C607
C609
1-126-514-11
1-163-031-11
1-126-786-11
1-163-031-11
1-164-004-11
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
22uF
0.01uF
47uF
0.01uF
0.1uF
20%
C610
C611
C612
C613
C614
1-124-233-11
1-124-464-11
1-163-017-00
1-163-037-11
1-163-022-00
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
10uF
0.22uF
0.0047uF
0.022uF
0.012uF
20%
20%
5%
10%
10%
16V
50V
50V
25V
50V
(CDX-3500)
C614
1-163-037-11 CERAMIC CHIP
0.022uF
10%
C615
1-163-022-00 CERAMIC CHIP
0.012uF
10%
C615
1-163-037-11 CERAMIC CHIP
0.022uF
10%
C617
C619
1-163-037-11 CERAMIC CHIP
1-163-018-00 CERAMIC CHIP
0.022uF
5600PF
10%
10%
25V
(CDX-2250)
50V
(CDX-3500)
25V
(CDX-2250)
25V
50V
(CDX-2250)
20%
10%
Ref. No.
Part No.
Description
Remark
C913
C914
1-163-021-11 CERAMIC CHIP
1-126-162-11 ELECT
0.01uF
3.3uF
C915
C916
1-124-257-00 ELECT
1-163-021-11 CERAMIC CHIP
2.2uF
0.01uF
10%
20%
50V
50V
(CDX-2250)
20%
50V
10%
50V
< CONNECTOR >
CNJ601
CNP701
CNP801
CNP901
16V
50V
16V
50V
25V
1-785-006-11
1-764-617-12
1-563-614-31
1-774-701-11
JACK (ANT)
PIN, CONNECTOR (PC BOARD) 30P
CONNECTOR, FLEXIBLE 11P
PIN, CONNECTOR 16P
< COMPOSITION CIRCUIT BLOCK >
CP601
C619
1-163-020-00 CERAMIC CHIP
0.0082uF 10%
C625
C701
C702
C703
1-163-037-11
1-163-021-11
1-163-235-11
1-163-235-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.022uF
0.01uF
22PF
22PF
50V
(CDX-3500)
10%
25V
10%
50V
5%
50V
5%
50V
C704
C705
C708
C709
C712
1-124-233-11
1-124-589-11
1-124-233-11
1-164-004-11
1-164-004-11
ELECT
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
10uF
47uF
10uF
0.1uF
0.1uF
20%
20%
20%
10%
10%
16V
16V
16V
25V
25V
C713
C714
C801
C802
C804
1-163-239-11
1-163-021-11
1-163-021-11
1-163-205-00
1-163-009-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
33PF
0.01uF
0.01uF
0.001uF
0.001uF
5%
10%
10%
5%
10%
50V
50V
50V
50V
50V
C805
C807
C808
C814
C830
1-163-009-11
1-163-233-11
1-163-234-11
1-163-038-00
1-164-222-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.001uF
18PF
20PF
0.1uF
0.22uF
10%
5%
5%
50V
50V
50V
25V
25V
C831
C901
C902
C903
C904
1-163-077-00
1-124-257-00
1-163-038-00
1-124-257-00
1-110-654-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
ELECT(BLOCK)
0.1uF
2.2uF
0.1uF
2.2uF
0.047F
10%
20%
C907
C908
C909
C910
C911
1-164-004-11
1-124-465-00
1-126-768-11
1-164-156-11
1-124-259-11
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP
ELECT
0.1uF
0.47uF
2200uF
0.1uF
4.7uF
10%
20%
20%
1-519-504-11 GAP, DISCHARGE
< DIODE >
D401
D402
D604
D701
D811
8-719-109-71
8-719-991-33
8-719-991-33
8-719-991-33
8-719-991-33
DIODE
DIODE
DIODE
DIODE
DIODE
RD3.9ES-B1
1SS133T-77
1SS133T-77
1SS133T-77 (CDX-2250)
1SS133T-77
D812
D901
D902
D903
D904
8-719-109-93
8-719-929-15
8-719-929-15
8-719-109-89
8-719-109-89
DIODE
DIODE
DIODE
DIODE
DIODE
RD6.2ESB2
MTZJ-T-77-9.1B
MTZJ-T-77-9.1B
RD5.6ESB2
RD5.6ESB2
D905
D906
D907
D908
D910
8-719-109-93
8-719-923-91
8-719-049-38
8-719-200-82
8-719-109-93
DIODE
DIODE
DIODE
DIODE
DIODE
RD6.2ESB2
MTZJ-T-77-16A
1N5404TU
11ES2
RD6.2ESB2
D911
D914
D916
D917
D918
8-719-991-33
8-719-200-82
8-719-200-82
8-719-200-82
8-719-200-82
DIODE
DIODE
DIODE
DIODE
DIODE
1SS133T-77
11ES2 (CDX-3500)
11ES2
11ES2
11ES2
D921
8-719-109-97 DIODE RD6.8ES-B2
< IC >
20%
0%
20%
25V
50V
25V
50V
0
25V
50V
16V
25V
16V
IC401
IC402
IC701
IC801
8-759-487-82
8-759-572-08
8-759-464-81
8-759-585-18
IC
IC
IC
IC
LC75374E
TDA7385
PCM1717E-ST2
uPD17705GC-537-3B9
< JUMPER RESISTOR >
JR3
JR4
JR4
JR5
JR6
1-216-295-00
1-216-296-00
1-216-864-11
1-216-296-00
1-216-296-00
SHORT
SHORT
METAL CHIP
SHORT
SHORT
0
0 (CDX-3500)
0
5%
0
0
JR7
JR11
JR13
JR14
JR15
1-216-296-00
1-216-296-00
1-216-295-00
1-216-296-00
1-216-295-00
SHORT
SHORT
SHORT
SHORT
SHORT
0
0
0
0
0
JR16
JR17
JR18
1-216-295-00 SHORT
1-216-296-00 SHORT
1-216-295-00 SHORT
0
0
0
– 46 –
1/16W
MAIN
Ref. No.
Part No.
Description
Remark
Ref. No.
Part No.
Description
Remark
JR19
JR22
1-216-296-00 SHORT
1-216-295-00 SHORT
0
0
Q915
Q916
8-729-822-84 TRANSISTOR 2SB1202FAST
8-729-027-43 TRANSISTOR DTC114EKA-T146
JR24
JR27
JR28
JR29
JR30
1-216-295-00
1-216-295-00
1-216-864-11
1-216-295-00
1-216-295-00
SHORT
SHORT
METAL CHIP
SHORT
SHORT
0
0
0
5%
0 (CDX-2250)
0 (CDX-2250)
Q917
Q918
8-729-101-07 TRANSISTOR 2SB798-DL
8-729-027-43 TRANSISTOR DTC114EKA-T146
JR31
JR33
JR34
JR35
JR36
1-216-296-00
1-216-295-00
1-216-295-00
1-216-296-00
1-216-296-00
SHORT
SHORT
SHORT
SHORT
SHORT
0
0
0
0
0
JR37
JR39
JR45
JR45
JR46
1-216-296-00
1-216-295-00
1-216-296-00
1-216-296-00
1-216-296-00
SHORT
SHORT
SHORT
SHORT
SHORT
0
0
0
0
0
JR46
JR47
JR48
JR60
JR86
1-216-296-00
1-216-296-00
1-216-295-00
1-216-295-00
1-216-295-00
SHORT
SHORT
SHORT
SHORT
SHORT
0
0 (CDX-2250)
0 (CDX-2250)
0
0 (CDX-2250)
JR90
1-216-295-00 SHORT
0
< COIL >
L601
L602
L801
L901
1-414-137-31
1-410-521-11
1-410-513-11
1-416-539-11
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
0.22uH
100uH
22uH
370uH
< JACK >
PJ401
1-785-628-11 JACK, PIN 4P LINE OUT
< TRANSISTOR >
1/16W
< RESISTOR >
R101
R102
R103
R104
R105
1-216-071-00
1-216-073-00
1-216-065-00
1-216-214-00
1-216-049-11
METAL CHIP
METAL CHIP
RES,CHIP
RES,CHIP
RES,CHIP
8.2K
10K
4.7K
4.7K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/8W
1/10W
R106
R107
R108
R109
R110
1-216-049-11
1-216-075-00
1-216-075-00
1-216-129-00
1-216-129-00
RES,CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
12K
12K
2.2M
2.2M
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R111
R112
R113
R201
R202
1-216-083-00
1-216-083-00
1-216-059-00
1-216-071-00
1-216-073-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
27K
27K
2.7K
8.2K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R203
R204
R205
R206
R207
1-216-065-00
1-216-065-00
1-216-049-11
1-216-049-11
1-216-075-00
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
METAL CHIP
4.7K
4.7K
1K
1K
12K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R208
R209
R210
R211
R212
1-216-075-00
1-216-129-00
1-216-129-00
1-216-083-00
1-216-083-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
12K
2.2M
2.2M
27K
27K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R213
R401
R402
R601
1-216-059-00
1-216-113-00
1-216-049-11
1-216-221-00
METAL CHIP
METAL CHIP
RES,CHIP
RES,CHIP
2.7K
470K
1K
9.1K
5%
5%
5%
5%
R601
1-216-230-00 RES,CHIP
22K
5%
1/10W
1/10W
1/10W
1/8W
(CDX-3500)
1/8W
(CDX-2250)
R602
R603
R604
1-249-417-11 CARBON
1-249-417-11 CARBON
1-216-077-00 METAL CHIP
1K
1K
15K
5%
5%
5%
R605
1-216-077-00 METAL CHIP
15K
5%
R607
1-216-025-00 RES,CHIP
100
5%
1/4W F
1/4W F
1/10W
(CDX-2250)
1/10W
(CDX-2250)
1/10W
Q101
Q102
Q201
Q202
Q401
8-729-920-21
8-729-920-21
8-729-920-21
8-729-920-21
8-729-027-52
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTC314TKH04
DTC314TKH04
DTC314TKH04
DTC314TKH04
DTC124EKA-T146
Q402
Q601
Q602
Q605
Q606
8-729-901-05
8-729-030-51
8-729-030-51
8-729-620-06
8-729-620-06
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTA124EK
2SA1515S-R-TP
2SA1515S-R-TP
2SC3052-EF
2SC3052-EF
Q801
Q901
Q902
Q904
Q905
8-729-027-43
8-729-019-00
8-729-901-05
8-729-015-11
8-729-027-43
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTC114EKA-T146
2SD2394-G
DTA124EK
2SD1802FAST-TL
DTC114EKA-T146
R608
R611
R612
R613
R614
1-216-081-00
1-216-049-11
1-216-049-11
1-216-049-11
1-216-049-11
METAL CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
22K
1K
1K
1K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
Q906
Q907
Q908
Q909
Q910
8-729-901-05
8-729-019-00
8-729-027-43
8-729-027-43
8-729-920-85
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTA124EK
2SD2394-G
DTC114EKA-T146
DTC114EKA-T146
2SD1664-QR
R615
R616
R617
R618
R620
1-249-429-11
1-249-417-11
1-216-049-11
1-216-057-00
1-247-807-31
CARBON
CARBON
RES,CHIP
METAL CHIP
CARBON
10K
1K
1K
2.2K
100
5%
5%
5%
5%
5%
1/4W
1/4W F
1/10W
1/10W
1/4W
Q911
Q912
Q913
8-729-620-06 TRANSISTOR 2SC3052-EF
8-729-620-06 TRANSISTOR 2SC3052-EF
8-729-027-43 TRANSISTOR DTC114EKA-T146
R622
R701
R702
1-216-081-00 METAL CHIP
1-216-025-00 RES,CHIP
1-216-025-00 RES,CHIP
22K
100
100
5%
5%
5%
1/10W
1/10W
1/10W
– 47 –
MAIN
Ref. No.
SERVO
Part No.
Description
Remark
R703
R704
1-216-025-00 RES,CHIP
1-216-033-00 METAL CHIP
100
220
5%
5%
1/10W
1/10W
R706
R707
R801
R804
1-216-037-00
1-216-027-00
1-216-053-00
1-216-105-00
330
120
1.5K
220K
5%
5%
5%
5%
R805
1-216-105-00 RES,CHIP
220K
5%
1/10W
1/10W
1/10W
1/10W
(CDX-3500)
1/10W
R806
R807
R808
R809
R810
1-216-053-00
1-216-053-00
1-216-057-00
1-216-073-00
1-216-105-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
RES,CHIP
1.5K
1.5K
2.2K
10K
220K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R812
R813
R814
R815
R817
1-216-073-00
1-216-073-00
1-216-049-11
1-216-049-11
1-216-057-00
METAL CHIP
METAL CHIP
RES,CHIP
RES,CHIP
METAL CHIP
10K
10K
1K
1K
2.2K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R818
R819
R820
R821
R822
1-216-057-00
1-216-061-00
1-216-057-00
1-249-417-11
1-249-417-11
METAL CHIP
METAL CHIP
METAL CHIP
CARBON
CARBON
2.2K
3.3K
2.2K
1K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/4W F
1/4W F
R823
R824
R825
R826
R827
1-216-049-11
1-216-105-00
1-216-105-00
1-216-105-00
1-216-234-00
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
1K
220K
220K
220K
33K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/8W
R828
R829
R830
R831
R832
1-216-254-00
1-216-254-00
1-216-254-00
1-216-089-00
1-216-073-00
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
METAL CHIP
220K
220K
220K
47K
10K
5%
5%
5%
5%
5%
1/8W
1/8W
1/8W
1/10W
1/10W
R833
R834
R836
R837
R839
1-216-049-11
1-216-049-11
1-216-049-11
1-249-441-11
1-216-049-11
RES,CHIP
RES,CHIP
RES,CHIP
CARBON
RES,CHIP
1K
1K
1K
100K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/4W
1/10W
R840
R841
R843
R844
R845
1-216-105-00
1-216-105-00
1-216-109-00
1-216-117-00
1-249-429-11
RES,CHIP
RES,CHIP
METAL CHIP
METAL CHIP
CARBON
220K
220K
330K
680K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/4W
R852
R901
R902
R903
R904
1-216-049-11
1-216-182-00
1-216-182-00
1-216-182-00
1-249-395-11
RES,CHIP
RES,CHIP
RES,CHIP
RES,CHIP
CARBON
1K
220
220
220
15
5%
5%
5%
5%
5%
1/10W
1/8W
1/8W
1/8W
1/4W F
R905
R906
R907
R908
R909
1-216-077-00
1-216-079-00
1-216-079-00
1-216-089-00
1-216-105-00
METAL CHIP
METAL CHIP
METAL CHIP
RES,CHIP
RES,CHIP
15K
18K
18K
47K
220K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R911
R912
R913
R914
R915
1-216-296-00
1-216-049-11
1-249-421-11
1-216-057-00
1-216-057-00
SHORT
RES,CHIP
CARBON
METAL CHIP
METAL CHIP
0
1K
2.2K
2.2K
2.2K
5%
5%
5%
5%
1/10W
1/4W F
1/10W
1/10W
METAL CHIP
METAL CHIP
METAL CHIP
RES,CHIP
Ref. No.
R916
R917
R918
R919
Part No.
Description
1-216-077-00
1-216-049-11
1-216-065-00
1-216-105-00
METAL CHIP
RES,CHIP
RES,CHIP
RES,CHIP
Remark
15K
1K
4.7K
220K
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
< SWITCH >
S802
1-571-478-11 SWITCH, SLIDE (CDX-3500)
< THERMISTOR >
TH901
1-809-148-11 THERMISTOR PTH8L07AR2R0M1B510
< TUNER >
TU01
A-3301-697-A TUNER UNIT
< VIBRATOR >
X701
X801
1-579-345-11 VIBRATOR, CERAMIC (16.9MHz)
1-760-223-11 VIBRATOR, CRYSTAL (4.5MHz)
**************************************************************
A-3309-227-A SERVO BOARD, COMPLETE
**********************
*
< CAPACITOR >
C1
C2
C3
C4
C5
1-107-823-11
1-163-021-11
1-135-145-11
1-163-251-11
1-164-182-11
CERAMIC CHIP
CERAMIC CHIP
TANTALUM CHIP
CERAMIC CHIP
CERAMIC CHIP
0.47uF
0.01uF
0.47uF
100PF
0.0033uF
10%
10%
10%
5%
10%
16V
50V
35V
50V
50V
C6
C7
C9
C10
C11
1-163-011-11
1-163-809-11
1-164-004-11
1-126-206-11
1-135-259-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
TANTAL. CHIP
0.0015uF
0.047uF
0.1uF
100uF
10uF
10%
10%
10%
20%
20%
50V
25V
25V
6.3V
6.3V
C12
C13
C14
C15
C16
1-163-227-11
1-163-021-11
1-163-989-11
1-163-021-11
1-163-989-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
10PF
0.01uF
0.033uF
0.01uF
0.033uF
0.5PF
10%
10%
10%
10%
50V
50V
25V
50V
25V
C17
C18
C19
C20
C21
1-164-004-11
1-164-004-11
1-163-037-11
1-107-823-11
1-163-809-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.022uF
0.47uF
0.047uF
10%
10%
10%
10%
10%
25V
25V
25V
16V
25V
C22
C23
C24
C25
C26
1-163-251-11
1-135-259-11
1-163-125-00
1-107-823-11
1-164-004-11
CERAMIC CHIP
TANTAL. CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100PF
10uF
220PF
0.47uF
0.1uF
5%
20%
5%
10%
10%
50V
6.3V
50V
16V
25V
C27
C28
C29
C30
C31
1-164-004-11
1-163-023-00
1-164-004-11
1-126-603-11
1-163-021-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
0.1uF
0.015uF
0.1uF
4.7uF
0.01uF
10%
5%
10%
20%
10%
25V
50V
25V
35V
50V
C32
C33
C34
C35
1-163-023-00
1-124-779-00
1-109-982-11
1-163-021-11
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
0.015uF
10uF
1uF
0.01uF
5%
20%
10%
10%
50V
16V
10V
50V
– 48 –
SERVO
Ref. No.
Part No.
Description
Remark
C36
1-164-004-11 CERAMIC CHIP
0.1uF
10%
25V
C37
C38
C39
C40
1-164-004-11
1-164-004-11
1-126-204-11
1-164-004-11
0.1uF
0.1uF
47uF
0.1uF
10%
10%
20%
10%
25V
25V
16V
25V
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
Ref. No.
JR41
JR43
JR44
JR45
JR46
Part No.
Description
1-216-296-00
1-216-296-00
1-216-296-00
1-216-296-00
1-216-296-00
SHORT
SHORT
SHORT
SHORT
SHORT
Remark
0 (CDX-2250)
0
0
0
0
< COIL >
< CONNECTOR >
CN1
CN2
CN3
1-764-616-12 HOUSING,CONNECTOR(PC BOARD)30P
1-565-728-51 CONNECTOR, FPC 17P
1-770-347-21 CONNECTOR, FPC 6P
L1
L2
L3
1-412-058-11 INDUCTOR CHIP 10uH
1-412-058-11 INDUCTOR CHIP 10uH
1-412-058-11 INDUCTOR CHIP 10uH
< TRANSISTOR >
< IC >
IC1
IC2
IC3
Q1
Q2
8-752-372-94 IC CXD2507AQ
8-752-074-34 IC CXA1782BQ
8-759-354-16 IC BA6796FP-T1
8-729-904-60 TRANSISTOR DTB113ZK
8-729-904-86 TRANSISTOR 2SB1197K-Q
< RESISTOR >
< JUMPER RESISTOR >
JR1
JR2
JR3
JR4
JR5
1-216-296-00
1-216-296-00
1-216-296-00
1-216-296-00
1-216-296-00
SHORT
SHORT
SHORT
SHORT
SHORT
0
0
0
0
0
JR6
JR7
JR8
JR9
JR10
1-216-296-00
1-216-296-00
1-216-296-00
1-216-296-00
1-216-296-00
SHORT
SHORT
SHORT
SHORT
SHORT
0
0
0
0
0
JR11
JR12
JR13
JR14
JR15
1-216-296-00
1-216-296-00
1-216-296-00
1-216-296-00
1-216-296-00
SHORT
SHORT
SHORT
SHORT
SHORT
0
0
0
0
0
JR16
JR17
JR18
JR19
JR20
1-216-296-00
1-216-296-00
1-216-296-00
1-216-296-00
1-216-296-00
SHORT
SHORT
SHORT
SHORT
SHORT
0
0
0
0
0
JR21
JR22
JR23
JR24
JR25
1-216-296-00
1-216-296-00
1-216-296-00
1-216-296-00
1-216-296-00
SHORT
SHORT
SHORT
SHORT
SHORT
0
0
0
0
0
JR26
JR27
JR28
JR29
JR30
1-216-296-00
1-216-296-00
1-216-296-00
1-216-296-00
1-216-296-00
SHORT
SHORT
SHORT
SHORT
SHORT
0
0
0
0
0
JR31
JR32
JR33
JR34
JR35
1-216-296-00
1-216-296-00
1-216-296-00
1-216-296-00
1-216-296-00
SHORT
SHORT
SHORT
SHORT
SHORT
0
0
0
0
0
JR36
JR37
JR38
JR39
JR40
1-216-296-00
1-216-296-00
1-216-296-00
1-216-296-00
1-216-296-00
SHORT
SHORT
SHORT
SHORT
SHORT
0
0
0
0
0
R1
R2
R3
R4
R5
1-216-073-00
1-216-097-00
1-216-121-00
1-216-061-00
1-216-061-00
METAL CHIP
RES,CHIP
RES,CHIP
METAL CHIP
METAL CHIP
10K
100K
1M
3.3K
3.3K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R6
R7
R8
R9
R10
1-216-073-00
1-216-009-00
1-216-119-00
1-216-119-00
1-216-073-00
METAL CHIP
RES,CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
22
820K
820K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R11
R14
R15
R16
R17
1-216-073-00
1-216-085-00
1-216-085-00
1-216-077-00
1-216-081-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
33K
33K
15K
22K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R19
R20
R21
R22
R23
1-216-079-00
1-216-105-00
1-216-105-00
1-216-085-00
1-216-121-00
METAL CHIP
RES,CHIP
RES,CHIP
METAL CHIP
RES,CHIP
18K
220K
220K
33K
1M
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R24
R27
R28
R29
R30
1-216-073-00
1-216-295-00
1-216-101-00
1-216-097-00
1-216-097-00
METAL CHIP
SHORT
METAL CHIP
RES,CHIP
RES,CHIP
10K
0
150K
100K
100K
5%
1/10W
5%
5%
5%
1/10W
1/10W
1/10W
R31
R32
R33
R34
R35
1-216-081-00
1-216-109-00
1-216-105-00
1-216-009-00
1-216-065-00
METAL CHIP
METAL CHIP
RES,CHIP
RES,CHIP
RES,CHIP
22K
330K
220K
22
4.7K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R36
R37
R38
R39
R40
1-216-097-00
1-216-117-00
1-216-109-00
1-216-101-00
1-216-114-00
RES,CHIP
METAL CHIP
METAL CHIP
METAL CHIP
RES,CHIP
100K
680K
330K
150K
510K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R41
R42
R43
R44
R45
1-216-093-00
1-216-103-00
1-216-097-00
1-216-085-00
1-216-081-00
RES,CHIP
METAL CHIP
RES,CHIP
METAL CHIP
METAL CHIP
68K
180K
100K
33K
22K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R45
R46
1-216-089-00 RES,CHIP
1-216-097-00 RES,CHIP
47K
100K
5%
5%
1/10W
1/10W
– 49 –
CDX-2250/3500
SERVO
Ref. No.
SUB
Part No.
Description
Remark
R47
R48
R49
1-216-105-00 RES,CHIP
1-216-073-00 METAL CHIP
1-216-065-00 RES,CHIP
220K
10K
4.7K
5%
5%
5%
1/10W
1/10W
1/10W
R50
R51
1-216-065-00 RES,CHIP
1-216-295-00 SHORT
4.7K
0
5%
1/10W
< VARIABLE RESISTOR >
RV1
RV4
1-238-091-11 RES, ADJ, CERMET 22K
1-238-091-11 RES, ADJ, CERMET 22K
**************************************************************
Ref. No.
Part No.
Description
Remark
*************
HARDWARE LIST
*************
#1
#2
#3
#4
#5
7-685-792-09
7-685-793-09
7-685-794-09
7-685-105-19
7-627-850-28
SCREW +PTT 2.6X6 (S)
SCREW +PTT 2.6X8 (S)
SCREW +PTT 2.6X10 (S)
SCREW +P 2X8 TYPE2 NON-SLIT
SCREW,PRECISION +P 1.4X3
#6
#7
#8
#9
7-627-000-00
7-628-253-00
7-627-553-37
7-627-553-17
SCREW,PRECISION +P1.7X2.2TYPE3
SCREW +PS 2X4
PRECISION SCREW +P 2X3 TYPE 3
PRECISION SCREW +P 2X2 TYPE 3
1-659-834-11 SUB BOARD
*********
*
**************************************************************
< CONNECTOR >
CN1
PARTSFOR INSTALLATION AND CONNECTIONS
**************************************
1-770-347-21 CONNECTOR, FPC 6P
**************************************************************
MISCELLANEOUS
*************
3
66
! 210
257
F901
TU01
LCD551
M901
M902
M903
1-769-786-81
1-783-268-11
8-820-010-06
1-769-786-81
1-532-877-11
A-3301-697-A
CORD (WITH CONNECTOR)
CABLE, FLAT
PICK-UP, OPTICAL KSS-521A/Q-NP
CORD (WITH CONNECTOR)
FUSE (BLADE TYPE) (AUTO FUSE) 10A
TUNER ASSY
1-803-439-21
X-3371-664-2
A-3291-674-A
A-3291-676-A
DISPLAY PANEL, LIQUID CRYSTAL
MOTOR ASSY (SPINDLE)
MOTOR ASSY, SLED
MOTOR SUB ASSY, LOADING
251
252
253
254
255
3-014-370-21
3-931-977-01
3-934-325-01
3-019-569-01
3-916-012-01
FRAME, FITTING
BRACKET
SCREW (+K 5X8 TP)
COLLAR
BRACKET (ND), FITTING ASSIST (CDX-2250)
256
257
258
259
X-3368-725-1
X-3366-405-1
1-769-786-81
3-035-161-01
SCREW ASSY, FITTING (CDX-2250)
SCREW ASSY (EXP), FITTING (CDX-3500)
CORD (WITH CONNECTOR) (POWER)
BRACKET (RELEASE)
**************************************************************
ACCESSORIES & PACKING MATERIALS
*******************************
3-865-650-11 MANUAL, INSTRUCTION, INSTALL
(ENGLISH,FRENCH)(CDX-2250)
3-865-650-21 MANUAL, INSTRUCTION, INSTALL
(ENGLISH,SPANISH,CHINESE)(CDX-3500)
3-865-652-11 MANUAL, INSTRUCTION (ENGLISH)(CDX-2250)
3-865-652-21 MANUAL, INSTRUCTION
(FRENCH)(CDX-2250:CND)
3-865-652-31 MANUAL, INSTRUCTION
(ENGLISH,SPANISH,CHINESE)(CDX-3500)
**************************************************************
The components identified by
mark ! or dotted line with mark
! are critical for safety.
Replace only with part number
specified.
Les composants identifiés par une
marque ! sont critiques pour la
sécurité.
Ne les remplacer que par une
piéce portant le numéro spécifié.
Sony Corporation
9-926-097-11
Personal & Mobile Communication Company
– 50 –
98L090238-1
Printed in Japan © 1998. 12
Published by Quality Assurance Dept.