No category

Download SERVICE MANUAL COMPACT DISC RECEIVER US model

100

101

102

103

104

105

106

107

108

109

110

111

112

113

114

Transcript

CX-BK1
SERVICE MANUAL
US Model
AEP Model
UK Model
E Model
Ver 1.0 2003.06
• CX-BK1 is the amplifier, CD player, tape deck
and tuner section in BMZ-K1.
• Tape deck is not loaded in US model.
Licensed by BBE Sound, Inc. under USP4638258, 5510752
and 5736897.
CD Section
TAPE Section
(Except US model)
Model Name Using Similar Mechanism
NEW
CD Mechanism Type
CDM69BV-30CBD64NS
Base Unit Name
BU-30CBD64NS
Optical Pick-up Name
A-MAX.3
Model Name Using Similar Mechanism
NEW
Tape Transport Mechanism Type
CMAL1Z240A
SPECIFICATIONS
TUNER
FM tuning range
FM usable sensitivity (IHF)
FM antenna terminal
AM tuning range
AM usable sensitivity
AM antenna
CD PLAYER
87.5 MHz to 108 MHz
13.2 dBf
75 Ω (unbalanced)
530 kHz to 1710 kHz (10 kHz step)
531 kHz to 1710 kHz (9 kHz step)
350 µ V/m
Loop antenna
AMPLIFIER
Power output
US model:
110 W + 110 W (40 Hz - 20 kHz,
THD less than 1%, 6 Ω)
140 W + 140 W (40 Hz - 20 kHz,
THD 10%, 6 Ω)
Chilean, Peruvian and Mexican models:
140 W + 140 W (1 kHz, THD
less than 1%, 6 Ω)
180 W + 180 W (1 kHz, THD
10%, 6 Ω)
Total harmonic distortion 0.08 % (90 W, 1 kHz, 6 Ω)
Input
LINE IN VIDEO: 1.0 Vp-p (75 Ω)
LINE IN AUDIO: 1.1 V
AUX (MD) IN: 1.1 V
MIC: 2.5mV (Chilean, Peruvian
and Mexican models)
Outputs
SPEAKERS: 6 Ω or more
PHONES: 32 Ω or more
AUX (MD) OUT: 500 mV
VIDEO OUT: 1.0 Vp-p (75 Ω)
Laser
D/A converter
Signal-to-noise ratio
Wow and flutter
Semiconductor laser (λ = 800 nm)
Emission duration: continuous
1 bit dual
85 dB (1 kHz, 0 dB)
Unmeasurable
CASSETTE DECK (Except US model)
Track format
Frequency response
Recording system
Heads
4 tracks, 2 channels stereo
100 Hz – 10000 Hz (± 3dB)
AC bias
Recording/playback × 1, erase × 1
GENERAL
Power requirements
US model:
120 V, 60 Hz
Mexican model:
127 V, 60 Hz
Chilean and Peruvian models:
120 V/220 – 230 V/240 V AC
(switchable), 50/60 Hz
Power consumption
US model:
120 W
Chilean and Peruvian models:
155 W
Mexican model:
160 W
Power consumption in standby mode
US model:
with ECO mode on: 0.25 W
with ECO mode off: 20 W
Chilean and Mexican models:
with ECO mode on: 0.25 W
with ECO mode off: 28 W
Dimensions (w/h/d)
Approx. 211 × 379 × 419 mm
(8 3/8 × 15 ×16 5/8 in.)
Mass
US model:
Approx. 8.6 kg (19 lbs)
Chilean and Peruvian models:
Approx. 9.9 kg
Specifications and external appearance are subject to change
without notice.
COMPACT DISC RECEIVER
US model
COMPACT DISC DECK RECEIVER
AEP, UK, Chilean, Peruvian and Mexican models
9-877-426-01
Sony Corporation
2003F05-1
C 2003.06
Home Audio Company
Published by Sony Engineering Corporation
CX-BK1
Notes on chip component replacement
• Never reuse a disconnected chip component.
• Notice that the minus side of a tantalum capacitor may be damaged by heat.
Flexible Circuit Board Repairing
• Keep the temperature of the soldering iron around 270 ˚C during repairing.
• Do not touch the soldering iron on the same conductor of the
circuit board (within 3 times).
• Be careful not to apply force on the conductor when soldering
or unsoldering.
CAUTION
Use of controls or adjustments or performance of procedures
other than those specified herein may result in hazardous radiation exposure.
The following caution label is located inside the unit.
CLASS 1 LASER PRODUCT
LUOKAN 1 LASER LAITE
KLASS 1 LASER APPARAT
This appliance is classified
as a CLASS 1 LASER
product.
SAFETY CHECK-OUT
After correcting the original service problem, perform the following safety check before releasing the set to the customer:
Check the antenna terminals, metal trim, “metallized” knobs,
screws, and all other exposed metal parts for AC leakage.
Check leakage as described below.
LEAKAGE TEST
The AC leakage from any exposed metal part to earth ground and
from all exposed metal parts to any exposed metal part having a
return to chassis, must not exceed 0.5 mA (500 microamperes.).
Leakage current can be measured by any one of three methods.
1. A commercial leakage tester, such as the Simpson 229 or RCA
WT-540A. Follow the manufacturers’ instructions to use these
instruments.
2. A battery-operated AC milliammeter. The Data Precision 245
digital multimeter is suitable for this job.
3. Measuring the voltage drop across a resistor by means of a
VOM or battery-operated AC voltmeter. The “limit” indication is 0.75 V, so analog meters must have an accurate lowvoltage scale. The Simpson 250 and Sanwa SH-63Trd are examples of a passive VOM that is suitable. Nearly all battery
operated digital multimeters that have a 2 V AC range are suitable. (See Fig. A)
This label is located on the
rear exterior.
To Exposed Metal
Parts on Set
0.15 µF
UNLEADED SOLDER
Boards requiring use of unleaded solder are printed with the leadfree mark (LF) indicating the solder contains no lead.
(Caution: Some printed circuit boards may not come printed with
the lead free mark due to their particular size)
1.5 k Ω
AC
voltmeter
(0.75 V)
Earth Ground
Fig. A. Using an AC voltmeter to check AC leakage.
: LEAD FREE MARK
Unleaded solder has the following characteristics.
• Unleaded solder melts at a temperature about 40 ˚C higher than
ordinary solder.
Ordinary soldering irons can be used but the iron tip has to be
applied to the solder joint for a slightly longer time.
Soldering irons using a temperature regulator should be set to
about 350 ˚C.
Caution: The printed pattern (copper foil) may peel away if the
heated tip is applied for too long, so be careful!
• Strong viscosity
Unleaded solder is more viscou-s (sticky, less prone to flow)
than ordinary solder so use caution not to let solder bridges occur such as on IC pins, etc.
• Usable with ordinary solder
It is best to use only unleaded solder but unleaded solder may
also be added to ordinary solder.
SAFETY-RELATED COMPONENT WARNING!!
COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED
LINE WITH MARK 0 ON THE SCHEMATIC DIAGRAMS
AND IN THE PARTS LIST ARE CRITICAL TO SAFE
OPERATION. REPLACE THESE COMPONENTS WITH
SONY PARTS WHOSE PART NUMBERS APPEAR AS
SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY.
2
CX-BK1
TABLE OF CONTENTS
1.
SERVICING NOTES ................................................ 4
2.
GENERAL
Location of Controls ....................................................... 6
3.
DISASSEMBLY
3-1.
3-2.
3-3.
3-4.
3-5.
3-6.
3-7.
3-8.
3-9.
3-10.
3-11.
3-12.
3-13.
3-14.
3-15.
3-16.
Disassembly Flow ...........................................................
Panel ................................................................................
Top Panel Block ..............................................................
Front Panel Assy .............................................................
MAIN Board ...................................................................
Rear Cover .......................................................................
Tuner (FM/AM) ..............................................................
SPEAKER Board ............................................................
ACDC Board, Power Transformer ..................................
AMP Board .....................................................................
CD Mechanism Deck (CDM69BV-30CBD64NS) .........
Signal Cassette Mechanism ............................................
Base Unit Section ............................................................
Base Unit (BU-30CBD64NS) .........................................
BD Board .........................................................................
SW (1) Board, SW (2) Board, SW (3) Board,
SW (4) Board, Bracket (Top) Assy .................................
CONNECTOR Board .....................................................
Motor (Stocker) Assy (Stocker) (M761) ........................
Motor (Roller) Assy (Roller) (M781) .............................
Motor (Mode) Assy (Mode) (M771) ..............................
Rubber Roller (Slider) Assy ...........................................
Timing Belt (Front/Rear) ................................................
Cam (Gear) ......................................................................
SENSOR Board ...............................................................
3-17.
3-18.
3-19.
3-20.
3-21.
3-22.
3-23.
3-24.
4.
8
9
9
10
10
11
11
12
12
13
13
14
14
15
15
16
16
17
17
18
18
19
19
20
ASSEMBLY
4-1.
4-2.
4-3.
4-4.
4-5.
How to Install the Cam (Eject Lock) ..............................
How to Install the Cam (Gear) ........................................
How to Install the Gear (Mode C) ..................................
How to Install the Gear (Mode Cam) .............................
How to Install the Rotary Encoder (S702),
Gear (Stocker Communication) ......................................
4-6. How to Install the Stocker Assy ......................................
21
21
22
22
23
23
8-12.
8-13.
8-14.
8-15.
8-16.
8-17.
8-18.
8-19.
8-38.
Printed Wiring Board – MAIN Board – ........................
Schematic Diagram – MAIN Board (1/4) – ..................
Schematic Diagram – MAIN Board (2/4) – ..................
Schematic Diagram – MAIN Board (3/4) – ..................
Schematic Diagram – MAIN Board (4/4) – ..................
Printed Wiring Board – USB AUX Board – ..................
Schematic Diagram – USB AUX Board – .....................
Printed Wiring Boars – MIC Board
(Chilean, Peruvian and Mexican models) – ...................
Schematic Diagram – MIC Board
(Chilean, Peruvian and Mexican models) – ...................
Schematic Diagram – AMP Board (1/2) – ....................
Schematic Diagram – AMP Board (2/2) – ....................
Printed Wiring Board – AMP Board – ..........................
Printed Wiring Board – HEADPHONE Board – ..........
Schematic Diagram – HEADPHONE Board – .............
Printed Wiring Board – SPEAKER Board – .................
Schematic Diagram – SPEAKER Board – ....................
Printed Wiring Boards – KEY Section – .......................
Schematic Diagram – KEY Section – ...........................
Printed Wiring Boards – LCD Section – .......................
Schematic Diagram – LCD Section – ...........................
Printed Wiring Board – ACDC Board – ........................
Schematic Diagram – ACDC Board – ...........................
Printed Wiring Board
– PT Board (US, AEP and UK models) – ......................
Schematic Diagram
– PT Board (US, AEP and UK models) – ......................
Printed Wiring Board – PT Board
(Chilean, Peruvian and Mexican models) – ...................
Schematic Diagram – PT Board
(Chilean, Peruvian and Mexican models) – ...................
IC Pin Function Description ...........................................
9.
EXPLODED VIEWS
9-1.
9-2.
9-3.
9-4.
9-5.
9-6.
9-7.
9-8.
Panel Section ...................................................................
Top Panel Block ..............................................................
Front Panel Block-1 ........................................................
Front Panel Block-2 ........................................................
Front Panel Block-3 ........................................................
Chassis Block-1 ...............................................................
Chassis Block-2 ...............................................................
CD Mechanism Deck Section-1
(CDM69BV-30CBD64NS) .............................................
CD Mechanism Deck Section-2
(CDM69BV-30CBD64NS) .............................................
CD Mechanism Deck Section-3
(CDM69BV-30CBD64NS) .............................................
CD Mechanism Deck Section-4
(CDM69BV-30CBD64NS) .............................................
CD Mechanism Deck Section-5
(CDM69BV-30CBD64NS) .............................................
CD Mechanism Deck Section-6
(CDM69BV-30CBD64NS) .............................................
Optical Pick-up Section (BU-30CBD64NS) ..................
8-20.
8-21.
8-22.
8-23.
8-24.
8-25.
8-26.
8-27.
8-28.
8-29.
8-30.
8-31.
8-32.
8-33.
8-34.
8-35.
8-36.
8-37.
5.
TEST MODE .............................................................. 24
6.
MECHANICAL ADJUSTMENTS ....................... 25
9-9.
7.
ELECTRICAL ADJUSTMENTS
9-10.
Deck Section ................................................................... 25
CD Section ...................................................................... 28
9-11.
8.
DIAGRAMS
9-12.
8-1.
8-2.
8-3.
8-4.
8-5.
Block Diagram – CD Section – .....................................
Block Diagram – TUNER/TAPE/USB Section – .........
Block Diagram – AMP Section – ..................................
Block Diagram – POWER SUPPLY Section – .............
Note for Printed Wiring Boards
and Schematic Diagrams ................................................
Printed Wiring Board – BD Board – .............................
Schematic Diagram – BD Board – ................................
Printed Wiring Boards – CHANGER Section – ............
Schematic Diagram – CHANGER Section – ................
Printed Wiring Board
– DECK Board (Except US model) – ............................
Schematic Diagram
– DECK Board (Except US model) – .............................
8-6.
8-7.
8-8.
8-9.
8-10.
8-11.
31
32
33
34
35
36
37
38
39
9-13.
9-14.
43
44
45
46
47
48
49
50
51
52
53
54
55
55
56
57
58
59
60
61
62
63
64
65
66
67
73
79
80
81
82
83
84
85
86
87
88
89
90
91
92
10. ELECTRICAL PARTS LIST ............................... 93
40
41
3
CX-BK1
SECTION 1
SERVICING NOTES
NOTES ON HANDLING THE OPTICAL PICK-UP
BLOCK OR BASE UNIT
• MODEL IDENTIFICATION
– Rear Cover –
The laser diode in the optical pick-up block may suffer electrostatic break-down because of the potential difference generated
by the charged electrostatic load, etc. on clothing and the human
body.
During repair, pay attention to electrostatic break-down and also
use the procedure in the printed matter which is included in the
repair parts.
The flexible board is easily damaged and should be handled with
care.
NOTES ON LASER DIODE EMISSION CHECK
The laser beam on this model is concentrated so as to be focused
on the disc reflective surface by the objective lens in the optical
pick-up block. Therefore, when checking the laser diode emission, observe from more than 30 cm away from the objective lens.
PART No.
LASER DIODE AND FOCUS SEARCH OPERATION
CHECK
Carry out the “S curve check” in “CD section adjustment” and
check that the S curve waveforms is output three times.
MODEL
PART No.
US model
4-245-039-0[]
Chilean and Peruvian models
4-245-039-1[]
AEP and UK models
4-245-039-2[]
Mexican model
4-245-039-3[]
SERVICE POSITION
– Tape mechanism deck (except US) –
Connect the wire (flat type) (11 core)
to the deck board (CN008) and the main board (CN009).
Connect the wire (flat type) (8 core)
to the main board (CN903) and
the mechanism deck.
4
CX-BK1
– CD mechanism deck –
• In checking the CD mechanism deck section, prepare three extension jigs (Part No. J-2501-242-A:1.00 mm 11core/
Part No. J-2501-245-A: 1.00 mm 23 core/Part No. J-2501-248-A: 1.00mm 27 core).
Note: The CD mechanism deck of this model is a vertical type and putting it vertically as shown in the figure is the standard position.
When checking signals such as RF waveforms, operate it with the CD mechanism deck in the standard position as shown below.
Connect the extension jig (J-2501-248-A)
to the connector board (CN701) and
the main board (CN901).
Connect the extension jig (J-2501-245-A)
to the BD board (CN102) and
the main board (CN902).
Connect the extension jig (J-2501-242-A)
to the BD board (CN104) and the main board (CN507).
– main board, ACDC board –
• For connecting the CD mechanism deck, prepare three extension jigs. (Refer to “– CD mechanism deck –”)
AMP board
speaker board
front panel section
PT board
ACDC board
main board
tuner unit
CD mechanism deck
5
CX-BK1
SECTION 2
GENERAL
This section is extracted from
instruction manual.
• LOCATION OF CONTROLS
Main unit: front
6 PLAY MODE (US model)
Selects various CD play mode.
@
1
2
3
4
5
6
7
8
9
0
!
#
$
%
^
&
*
(
)
1 POWER 6STANDBY/ON
Switches the unit on and off (standby).
2 FUNCTION
Switches the active function among CD, USB, TAPE
(Except US model), TUNER, VIDEO and AUX.
3 BAND
Select tuner function and the tuner band.
4 GEQ
Selects a sound equalization curve.
i-Bass
Produces rich and clear low frequency sound.
5 TREBLE/MIDDLE
Adjusts the treble or middle range level.
BASS
Adjusts the bass level.
wREC (Except US model)
Starts tape recording.
Also used to enter 4-second blank spaces during
recording.
7 TUNING DOWNf/r, UPg/t
CD: skips to a previous or a succeeding track when
pressed, searches a track in fast forward or reverse
playback when held down.
Tape: rewinds or fast forwards the tape. (Except US
model)
Tuner: manually tunes up or down within the band.
# TITLE
When the unit is turned off: activates or deactivated
DEMO.
Changes the display in MP3-CD or USB source.
DISPLAY
Changes the display in CD playback mode.
Turns the back light on and off when the unit is turned
off.
MODE
Selects various modes (sound adjustment, etc.) when
used in combination with ENTER and MULTI JOG.
Switches the ECO mode on and off when the unit is turned
off.
8 USB terminal
Accepts sound signals from a personal computer.
Connect your personal computer to this terminal with a
USB cable so that the unit can output the sound of an
audio file which is played back by the Winamp3 on your
computer.
Be sure to see “CONNECTING A PERSONAL
COMPUTER” for the details about the computer
requirements, how to connect and so on before actually
connecting your computer.
$ aPAUSE/SET
Pauses CD play.
9 LINE IN (VIDEO/AUDIO) jacks
Accepts analog signals from external equipment.
Connect using an optional connecting cable with RCA
phono plugs (red plug to R jack, white plug to L jack,
yellow plug to VIDEO jack).
Refer also to the operating instructions of your equipment.
To switch function to external input, press FUNCTION
repeatedly to display “VIDEO”.
% MULTI JOG
When used in combination with ENTER and MULTI JOG,
CD: selects a track.
Tuner: selects a preset station.
sSTOP/CLEAR
Stops CD play.
cPRESET (US model)
Starts CD play.
dPRESET (Except US model)
Starts CD or tape play.
^ ENTER
Fixes the modes and the time (clock and timer, etc.) when
used in combination with ENTER and MULTI JOG.
0 zEJECT
Ejects the disc(s).
& PHONES jack
Plug in optional headphones set with a stereo mini plug
(Ø3.5 mm). Speaker output is canceled.
! DISC SELECT (1-5)
Selects a disc slot.
Starts CD play for one desired disc.
* MIC MIXING (Chilean and Peruvian
models)
Adjusts the microphone volume.
@ VOLUME
Adjusts the volume.
( MIC jack (Chilean and Peruvian models)
Connects the microphone.
) ALBUM/PLAY LIST k,i
Skips to a previous or succeeding album or play list.
1 AM LOOP jack and FM 75 Ω terminal
Plug in the supplied AM and FM antennas.
Main unit: rear
1
2
3
4
5
6
2 AUX IN jacks
Accept analogue sound signals from external equipment.
Connect external equipment using an optional connecting
cable with RCA phono plugs (red plug to R jack, white
plug to L jack). Refer also to the operating instructions
for your equipment.
To switch function to external input, press FUNCTION
repeatedly to display “AUX” (US model) or “MD”
(Chilean, Peruvian and Mexican models).
3 AUX OUT jacks
Analog sound signals for all functions can be output
through these jacks. Use a cable with RCA phono plugs
to connect audio equipment.
Connect the red plug to the R jack, and the white plug to
the L jack.
However, the signal is not output when the function is
“VIDEO” or “AUX” (US model) or “MD” (Chilean,
Peruvian and Mexican models).
4 VIDEO OUT
Signals from VIDEO IN jack output through this jack.
5 #SPEAKERS terminals
Connect the speaker cords of the supplied speakers.
6 AC power cord
6
CX-BK1
Remote commander
Refer to the pages indicated in parentheses for details.
1
8
KARAOKE (Chilean, Peruvian and
Mexican models)
Selects a Karaoke mode.
GEQ
2
9
3
4
5
6
7
TUNER MODE
Switches between stereo or monaural FM reception.
0
!
@
Buttons with the same or similar names on the main unit
basically have the same function.
1 POWER
2 1-9, 0/10, +10
CD: selects a track of the specified number.
Tuner: tunes in the station with the specified preset
number.
The numbered buttons take on these functions when
pressed with SHIFT held down.
EDIT (Chilean, Peruvian and Mexican
models)
Selects edited CD recording.
BAND
SPECTRUM
Changes the spectrum analyser display.
3 c/d
Starts CD play.
7 SHIFT
Hold down when pressing a numbered button to change
its function to that printed above the number.
8 FUNCTION
9 DISC SKIP
Changes a disc slot.
0 ENTER
s
! SLEEP
Selects sleep-timer mode.
a
@ VOLUME +, -
f/g
r/tPRESET
Tuner: selects a preset station.
M/N ALBUM
Selects a previous or a succeeding album.
4 PLAY MODE
REPEAT
Selects repeat CD playback mode.
5 CLOCK/TIMER SET
Enters clock and timer setting mode.
CLOCK/TIMER SELECT
Switches timer setting on and off.
6 DISPLAY
SOUND
Selects bass, treble or middle range level setting mode.
CLEAR
Clears a track of the CD programed playback and a tuner
preset station.
Setting the clock
1 Press CLOCK/TIMER SET on the remote.
See below when to adjust the clock.
2 Press r or t to set the hour, then press
ENTER.
3 Press r or t to set the minute.
Each press changes the time in 1-minute steps.
4 Press ENTER.
The time display stops flashing and the clock starts from
00 seconds.
•MULTI JOG is also available in place of r or t.
To adjust the clock
1 Press CLOCK/TIMER SET on the remote.
2 Press r or t repeatedly to display “CLOCK” and
then press ENTER.
3 Carry out steps 2 to 4 described in “Setting the clock” to set
the time.
To display the time while the power is on
Press DISPLAY repeatedly. The clock display appears in the
display for 6 seconds.
If “- -:- -” appears when the unit is turned off
There has been a power interruption. Reset the clock.
7
CX-BK1
SECTION 3
DISASSEMBLY
• This set can be disassembled in the order shown below.
3-1.
DISASSEMBLY FLOW
Note 1: The process described in
SET
can be performed in any order.
Note 2: Without completing the process described in
, the next process can not be performed.
Note 3: Tape deck is not loaded in US model.
3-2. PANEL
(Page 9)
3-3. TOP PANEL BLOCK
(Page 9)
3-4. FRONT PANEL
ASSY
(Page 10)
3-6. REAR COVER
(Page 11)
3-7. TUNER (FM/AM)
(Page 11)
3-8. SPEAKER
BOARD
(Page 12)
3-12. SIGNAL
CASSETTE
MECHANISM
(Page 14)
3-5. MAIN BOARD
(Page 110)
3-7. TUNER (FM/AM)
(Page 11)
3-8. SPEAKER BOARD
(Page 12)
3-9. ACDC BOARD, POWER TRANSFORMER
(Page 12)
3-10. AMP BOARD
(Page 13)
3-11. CD MECHANISM DECK
(CDM69BV-30CBD64NS)
(Page 13)
3-13. BASE UNIT SECTION
(Page 14)
3-14. BASE UNIT
(BU-30CBD64NS)
(Page 15)
3-15. BD BOARD
(Page 15)
3-16. SW (1) BOARD,
SW (2) BOARD,
SW (3) BOARD,
SW (4) BOARD,
BRACKET (TOP) ASSY
(Page 16)
3-19. MOTOR (ROLLER)
ASSY (ROLLER)
(M781)
(Page 17)
3-18. MOTOR (STOCKER)
ASSY (STOCKER)
(M761)
(Page 17)
3-17. CONNECTOR BOARD
(Page 16)
3-21. RUBBER ROLLER
(SLIDER) ASSY
(Page 18)
3-20. MOTOR (MODE)
ASSY (MODE)
(M771)
(Page 18)
3-22. TIMING BELT
(FRONT/REAR)
(Page 19)
3-23. CAM (GEAR)
(Page 19)
3-24. SENSOR BOARD
(Page 20)
8
CX-BK1
Note: Follow the disassembly procedure in the numerical order given.
3-2.
1 three screws
(BVTP3 × 10)
PANEL
• Tape deck is not loaded in US model.
The shape of the top panel shown in
“DISASSEMBLY” is different from the
actual shape.
6 three screws
(BVTP3 × 10)
3 four claws
4
9
2 four screws
(BVTP3 × 10)
0 right panel
5 panel (left)
8 four claws
7 four screws
(BVTP3 × 10)
3-3.
TOP PANEL BLOCK
• Tape deck is not loaded in US model.
The shape of the top panel shown
in “DISASSEMBLY” is different from
the actual shape.
4 wire (flat type) (8core)
(CN903)
3
2 three claws
6 top panel block
1 three screws
(BVTP3 × 10)
5 wire (flat type) (11core)
(CN009)
9
CX-BK1
E51, MX
3-4.
FRONT PANEL ASSY
3 wire (flat type) (5core)
(CN504)
2 wire (flat type) (17core)
(CN004)
1 wire (flat type) (19core)
(CN905)
9 front panel assy
6 two screws
(BVTP3 × 10)
8 two claws
4 connector (CN530)
5 five screws
(BVTP3 × 10)
3-5.
7 six screws
(BVTP3 × 10)
MAIN BOARD
2 wire (flat type)
(11core: US, E51) (CN509)/
(15core: AEP, UK) (CN508)
1 wire (flat type) (11core)
(CN502)
6 wire (flat type) (11core)
(CN507)
5
7 connector
(CN007)
qs main board
3 two screws
(BVTP3 × 10)
8 connector
(CN006)
4 screw
(BVTP3 × 10)
qa two screws
(BVTP3 × 6)
0 wire (flat type) (27core)
(CN901)
9 wire (flat type) (23core)
(CN902)
10
CX-BK1
3-6.
REAR COVER
1 seven screws
(BVTP3 × 10)
3 connector
(CN303)
4 rear cover
2
3-7.
TUNER (FM/AM)
2 tuner (FM/AM)
1 two screws
(BVTP3 × 8)
11
CX-BK1
3-8.
SPEAKER BOARD
2 two screws
(BVTP3 × 10)
3 speaker board
1 connector
(CN503)
3-9.
ACDC BOARD, POWER TRANSFORMER
1 connector (CN003)
4 two screws
(BVTP3 × 10)
2 connector (CN006)
6 ACDC board
5 seven screws
(BVTP3 × 10)
3 connector (CN011)
7 connector
(E51, MX: CN015)/
(US: CN011)/
(AEP, UK: CN001)
8 connector
(CN008)
E51
9 two screws
(ITC+4-8)
0 power transformer
8 connector
(CN010)
EXCEPT E51
12
CX-BK1
3-10. AMP BOARD
4 two screws
(BVTP3 × 10)
3 two screws
(BVTP3 × 10)
5 AMP board
2 CD support board
1 two screws
(BVTP3 × 10)
3-11. CD MECHANISM DECK (CDM69BV-30CBD64NS)
1 four screws
(BVTP3 × 10)
5 disk mecanical holder
4 four screws
(BVTP3 × 10)
2 four screws
(BVTP3 × 10)
6 CD mechanism deck
(CDM69BV-30CBD64NS)
3 disk mechanical cover
13
CX-BK1
3-12. SIGNAL CASSETTE MECHANISM
• Tape deck is not loaded in US model.
1 connector
(CN302)
3 signal cassette mechanism
2 four screws
(BVTP3 × 10)
3-13. BASE UNIT SECTION
2 screw (+PTPWH) (M2) (DIA. 7)
3 boss
1 floating screw (DIA. 12)
4 boss
7 base unit section
14
6 boss
5 boss
CX-BK1
3-14. BASE UNIT (BU-30CBD64NS)
qa base unit (BU-30CBD64NS)
1 tension spring (BU30-1)
4 floating screw
(+PTPWHM2.6 × 6)
9 vibration proof rubber
5 floating screw
(+PTPWHM2.6 × 6)
3 floating screw
(+PTPWHM2.6 × 6)
q; vibration proof rubbers
8 vibration proof rubber
6
2 floating screw
(+PTPWHM2.6 × 6)
7 vibration proof rubber
3-15. BD BOARD
4 wire (flat type) (16 core)
2 wire (flat type) (11 core)
3 Remove the solder
(four portions).
5 BD board
1 wire (flat type) (23 core)
15
CX-BK1
3-16. SW (1) BOARD, SW (2) BOARD, SW (3) BOARD, SW (4) BOARD, BRACKET (TOP) ASSY
4 SW (3) board
3 SW (2) board
5 SW (4) board
1 four screws
(BTP2.6 × 6)
6 six screws
(BVTP2.6 × 8)
2 SW (1) board
7 bracket (top) assy
3-17. CONNECTOR BOARD
– bottom view –
4 connector
(CN710)
5 connector
(CN703)
3
CONNECTOR board
2 four screws
(BVTP2.6 × 8)
6 CONNECTOR board
1 Remove five solders.
16
CX-BK1
3-18. MOTOR (STOCKER) ASSY (STOCKER) (M761)
3 two screws
(BVTP2.6 × 8)
4
2 Remove two solders
5 stocker motor board
6 motor (stocker) assy
(stocker) (M761)
1 belt (stocker)
3-19. MOTOR (ROLLER) ASSY (ROLLER) (M781)
3 two screws
2 Remove two solders.
4 ROLLER MOTOR board
5 motor (roller) assy
(roller)(M781)
1 belt (roller V)
17
CX-BK1
3-20. MOTOR (MODE) ASSY (MODE) (M771)
3 two screws
(BVTP2.6 × 8)
1 Remove five solders
of rotary encoder.
4 MODE MOTOR board
6 motor (mode) assy
(mode) (M771)
MODE MOTOR
board
2 Remove two solders
of motor (M771)
5 belt (mode V)
3-21. RUBBER ROLLER (SLIDER) ASSY
8 step screw
0 rubber roller
(slider 4) assy
9 tension
spring
(slider 2)
5 step screw
6 tension spring
(base slider 4)
qa rubber roller
(slider 2) assy
1 step screw
2 rubber roller
(slider S) assy
3 tension spring
(base slider 5)
qs step screw
7 rubber roller
(slider 1) assy
qd rubber roller
(slider 1) assy
qf screw
(BVTP2.6 × 8)
qg sub chassis
18
4 rubber roller
(slider 5) assy
CX-BK1
3-22. TIMING BELT (FRONT/REAR)
3 slider (mode cam) assy
7 two gears (center)
When install three timing belts,
its pass under each claws.
8 timing belt (rear)
timing belt
(rear)
5 two gears
(center)
9 timing belt (rear)
claw
6 timing belt
(front)
claw
timing belt
(rear)
claw
claw
4 gear
(timing)
timing belt (front)
2 gear (mode cam)
: Note
Note: Refer to assembly (Section 4)
1 screw
(PTPWH2.6 × 8)
3-23. CAM (GEAR)
qf cam (gear)
: Note
6 gear (mode 5)
qd screw
5 screw (PTPWH2.6 × 8)
4 gear (mode 5)
qs gear(mode cam)
3 screw (PTPWH2.6 × 8)
qa screw
(PTPWH2.6 × 8)
2 pulley
(mode deceleration)
0 gear (mode C)
:Note
Note: Refer to assembly
(Section 4).
9 screw
(PTPWH2.6 × 8)
1 screw(PTPWH2.6 × 8)
8 gear (mode D)
7 screw (PTPWH2.6 × 8)
19
CX-BK1
3-24. SENSOR BOARD
ql harness
qk claw
q; cam (eject lock)
: Note
9 screw
(PTPWH2.6 × 8)
qh two claws
qd gear (eject lock)
qs cam (BU U/D)
8 shaft
(shutter)
7 compression spring
(shutter)
w; screw
(BVTP2.6 × 8)
qa screw
(PTPWH2.6 × 8) 3 screw
(BVTP2.6 × 8)
20
qg screw
(PTPWH2.6 × 8)
6 gear (mode A)
5 base (shutter) block
1 screw
(PTPWH2.6 × 8)
qj rotary encoder
(S771)
wa SENSOR board
qf gear
(mode B)
Note: Refer to assembly (Section 4).
4 two screws
(BVTP2.6 × 8)
2 lever shutter (A)
CX-BK1
SECTION 4
ASSEMBLY
• This set can be assembled in the order shown below.
4-1.
HOW TO INSTALL THE CAM (EJECT LOCK)
1 Rotate the cam (BU U/D) fully in the direction of arrow.
2 Engage the gear (eject lock) and the gear of the cam (eject lock)
aligning the mark with the center of the gear (eject lock).
cam (BU U/D)
mark
gear (eject lock)
cam (eject lock)
– bottom view • front –
4-2.
HOW TO INSTALL THE CAM (GEAR)
1 Check that the cam (BU U/D) can not be rotated in the direction of arrow.
2 Align the mark on the cam (gear) with the boss as shown in the figure
and install the cam (gear).
cam (gear)
boss
cam (BU U/D)
mark
– bottom view • front –
21
CX-BK1
4-3.
HOW TO INSTALL THE GEAR (MODE C)
1 Align the mark on the rotary encoder (S771) with the projection of the assy.
2 Check that the cam (BU U/D) can not be rotated in the direction of arrow.
3 Install the gear (mode C)
rotary encoder
(S771)
cam (BU U/D)
gear (mode C)
mark
chassis
projection
– bottom view • front –
4-4.
HOW TO INSTALL THE GEAR (MODE CAM)
1 Slide the shaft in the direction of arrow.
2 Align mark A on the gear (mode cam) with mark B on the slider (mode cam) assy,
then install the gear (mode cam).
3 Check that mark C on the gear (mode cam) is in alignment with mark D on the cam (gear).
shaft
mark A
slider (mode cam) assy
gear (mode cam)
mark D
mark B
mark C
cam (gear)
– bottom view • front –
22
CX-BK1
4-5.
HOW TO INSTALL THE ROTARY ENCODER (S702), GEAR (STOCKER COMMUNICATION)
4 gear
(stocker communication)
5 screw
(PTPWH2.6 × 8)
3 screw
(PWH2 × 6)
Engage the rotary encoder (S702)
and the gear (stocker communication)
as shown below in the figure.
7 two screws
(PTPWH2.6 × 8)
1 rotary encoder
(S702)
6 two gears
(stocker communication)
rotary encoder
(S702)
2 five solders
gear
(stocker
communication)
CONNECTOR board
– rear –
4-6.
HOW TO INSTALL THE STOCKER ASSY
boss
Install the stocker assy
fitting three bosses into the
each groove of cam
then fix by rotating the cams
in the direction of arrow.
3 screw
(PTPWH2.6 × 8)
2 cam
(stocker V)
boss
5 two screws
(PTPWH2.6 × 8)
4 two cams
(stocker U/D)
cam
To install three cams, align each groove
of the cam with each f mark on the
chassis as shown in the figure.
rotary encoder
(S702)
hole
screw
1 Position the hole on the gear
(stocker communication) on the
screw of the rotary encoder (S702).
gear
(stocker communication)
– rear –
23
CX-BK1
SECTION 5
TEST MODE
[Cold Reset]
* The cold reset clears all data including preset data stored in
the RAM to initial conditions. Execute this mode when returning the set to the customer.
Procedure:
1. Press the POWER 1 button to turn off the main power.
2. While depressing the x button, press the POWER 1 button.
3. The fluorescent indicator tube does not display any message
and the set is reset.
[Version Display Mode]
* The version of the microcomputer is displayed.
Procedure:
1. Press the POWER 1 button to turn the set on.
2. To enter the test mode, press two buttons x and POWER 1
simultaneously for more than five seconds. The version of the
microcomputer is displayed.
[FL Tube Check]
* All fluorecent segments are tested.
Procedure:
1. Insert a disc, and extract an AC plug.
2. While depressing the [FUNCTION] button, insert an AC plug
to enter the test mode.
3. The message “CD TEST” is displayed, the initialization is
performed.
Then all segments of the fluorecent indicator tube are turned on.
[CD Ship Mode]
* This mode moves the optical pick-up to the position durable
to vibration. Use this mode when returning the set to the customer after repair.
Procedure:
1. Press the POWER 1 button to turn the set on.
2. Set the FUNCTION to CD.
3. Press the x button for more than five seconds.
4. After a message “MECHA LOCK” is displayed on the fluorescent indicator tube, the CD ship mode is set and the power
is turned off.
[Disc Tray Lock]
The disc tray lock function for the antitheft of an demonstration
disc in the store is equipped.
Setting Procedure :
1. Press the POWER 1 button to turn the set on.
2. Press two buttons of x and Z simultaneously for five seconds.
3. The message “LOCKED” is displayed and the tray is locked.
Releasing Procedure :
1. Press two buttons of x and Z simultaneously for five seconds again.
2. The message “UNLOCKED” is displayed and the tray is unlocked.
Note : When “LOCKED” is displayed, the tray lock is not released
by turning power on/off with the POWER 1 button.
[AMP Test]
* This mode is used to check the function of the amplifier.
Procedure:
1. Extract an AC plug.
2. While depressing the [GEQ] button, insert an AC plug to enter the AMP test mode. The message “AMP TEST” is displayed.
3. The message “Volume MAX” is displayed, when the [VOLUME] knob is rotated clockwise. The message “Volume 0” is
displayed, when the [VOLUME] knob is rotated counterclockwise.
4. Each time the [BASE] or [TREBLE] knob is turned, the mes-
24
sage “EQ MAX”, “EQ MIN” or “EQ FLAT” is displayed in
this order.
[AM Channel Step 9 kHz/10kHz Selection Mode]
* Either the 9 kHz step or 10 kHz step can be selected for the
AM channel step.
Procedure:
1. Set the FUNCTION to AM.
2. While depressing the [BAND] button, press the POWER 1 button.
3. The channel step is changed over.
[CD Test Mode]
* This mode can run the CD sled motor freely. Use this mode,
for instance, when cleaning the pickup.
Procedure:
1. Extract an AC plug.
2. While depressing the [FUNCTION] button, insert an AC plug
to enter the CD test mode. The message “CD TEST” is displayed.
3. With the CD in stop status, press the > button to move the
pickup to outside track, or press the . button to inside track.
4. When press the B button, normal playback is performed.
5. Each time the B button is pressed during normal playback,
the tracking servo is switched on or off.
[CD Repeat 5 Times Limit Release Mode]
Procedure:
1. Press the POWER 1 button to turn the set on.
2. Select the FUNCTION to CD.
3. Press three buttons of x and [FUNCTION] and B simultaneously.
4. The repeat all mark blinks and then repeat 5 times limit is
released.
CX-BK1
SECTION 6
MECHANICAL ADJUSTMENTS
• TAPE MECHANISM DECK SECTION
SECTION 7
ELECTRICAL ADJUSTMENTS
DECK SECTION
0 dB = 0.775 V
Note: Tape deck is not loaded in US model.
Note: Tape deck is not loaded in US model.
Precaution
1. Clean the following parts with a denatured alcohol-moistened
swab:
record/playback heads
pinch rollers
erase head
rubber belts
capstan
idlers
2. Demagnetize the record/playback head with a head
demagnetizer.
3. Do not use a magnetized screwdriver for the adjustments.
4. After the adjustments, apply suitable locking compound to the
parts adjusted.
5. The adjustments should be performed with the rated power
supply voltage unless otherwise noted.
Precaution
1. Demagnetize the record/playback head with a head
demagnetizer.
2. Do not use a magnetized screwdriver for the adjustments.
3. After the adjustments, apply suitable locking compound to the
parts adjust.
4. The adjustments should be performed with the rated power
supply voltage unless otherwise noted.
5. The adjustments should be performed in the order given in
this service manual. (As a general rule, playback circuit adjustment should be completed before performing recording
circuit adjustment.)
6. The adjustments should be performed for both L-CH and RCH.
7. Switches and controls should be set as follows unless otherwise specified.
Torque Measurement
Mode
FWD
FWD
back tension
Torque meter
CQ-102C
CQ-102C
REV
CQ-102RC
REV
back tension
CQ-102RC
FF/REV
FWD tension
REV tension
CQ-201B
CQ-403A
CQ-403R
Meter reading
2.94 – 7.84 mN • m
(30 to 79 g • cm)
(0.42 – 1.11 oz • inch)
0.15 – 0.6 mN • m
2 to 6 g • cm
(0.03 – 0.08 oz • inch)
2.94 – 7.84 mN • m
(30 to 79 g • cm)
(0.42 – 1.11 oz • inch)
2.94 – 7.84 mN • m
(30 to 79 g • cm)
(0.42 – 1.11 oz • inch)
6.86 – 17.64 mN • m
(70 to 179 g • cm)
(0.98 – 2.49 oz • inch)
9.8 mN • m
(100 • cm or more)
(1.4 oz • inch or more)
9.8 mN • m
(100 • cm or more)
(1.4 oz • inch or more)
• Test Tape
Tape
Signal
Used for
P-4-A100
10 kHz, – 10 dB
Azimuth Adjustment
WS-48B
3 kHz, 0 dB
Tape Speed Check
Record/Playback Head Azimuth Adjustment
Procedure:
1. Mode: Playback
test tape
P-4-A100
(10 kHz, – 10 dB)
SPEAKER board
SPEAKER terminal (JK502)
L-CH, R-CH
level meter
set
+
–
2. Turn the adjustment screw and check output peaks. If the peaks
do not match for L-CH and R-CH, turn the adjustment screw
so that outputs match within 1dB of peak.
within
1dB
L-CH
peak
within
1dB
Output
level
Screw
position
R-CH
peak
L-CH
peak
R-CH
peak
Screw
position
25
CX-BK1
3. Mode: Playback
SPEAKER board
SPEAKER terminal (JK502)
L-CH
oscilloscope
test tape
P-4-A100
(10 kHz, – 10 dB)
L-CH
V
set
Record Bias Adjustment
Procedure:
1. Record mode
H
AF OSC
MAIN board
AUX IN jack (JK602)
1) 315 Hz 
50 mV (–23.8 dB)
2) 10 kHz 
attenuator
R-CH
R-CH
blank tape
CN-123
600 Ω
set
waveform of oscilloscope
2.
in phase 45 °
good
90 ° 135 ° 180 °
wrong
4. After the adjustments, apply suitable locking compound to the
parts adjusted.
Mode: Playback
i-Bass OFF
BASS 0
TREBLE 0
recorded
portion
Adjustment Location: Record/Playback/Erase Head
level meter
set
+
–
SPEAKER board SPEAKER terminal (JK502)
3.
4.
adjustment screw
Confirm playback the signal recorded in step 1 become
adjustment level as follows.
If these levels do not adjustment level, adjustment the SFR451
(L-CH) and SFR452 (R-CH) to repeat steps 1 and 4.
Adjustment level: Playback output of 315 Hz to playback output
of 10 kHz: 0 ± 1.0 dB (0 ± 4.5mV).
Adjustment Location: DECK board (Page 27)
Tape Speed Check
Mode: Playback
test tape
WS-48B
(3 kHz, 0 dB)
frequency counter
set
+
–
SPEAKER board
SPEAKER terminal (JK502)
L-CH, R-CH
1. Insert the WS-48B into the deck.
2. Press the B button.
3. Confirm that the frequency counter reads 3,000 ± 90 Hz.
Sample value of Wow and Flutter: 0.3% or less W.RMS (JIS)
(WS-48B)
26
CX-BK1
– DECK Board (Component Side) (Except US model) –
SFR451
Record Bias
Adjustment
(L-CH)
SFR452
Record Bias
Adjustment
(R-CH)
– MAIN Board (Conductor Side) –
JK602
AUX IN jack (R-CH)
AUX IN jack (R-CH)
– SPEAKER Board (Conductor Side) –
SPEAKER terminal
(R-CH)
SPEAKER terminal
(L-CH)
JK602
27
CX-BK1
RFDC signal waveform
CD SECTION
VOLT/DIV: 200 mV
TIME/DIV: 500 ns
Note:
1. Use YEDS-18 disc (3-702-101-01) unless otherwise indicated.
2. Use an oscilloscope with more than 10MΩ impedance.
3. Clean the object lens by an applicator with neutral detergent when the
signal level is low than specified value with the following checks.
level: 0.6 ± 0.15 Vp-p
S-curve Check
Connection:
oscilloscope
BD board
TP (FE)
TP (VC)
Checking Location: CD board (Conductor side)
RFAC Level Check
Connection:
+
–
oscilloscope
Procedure:
1. Connect an oscilloscope to test point TP (FE) and TP (VC)
on the BD board.
2. While depressing the B button, insert an AC plug.
3. Put the disc (YEDS-18) in and press the x button and
actuate the focus search. (actuate the focus search when disc
table is moving in and out)
4. Check the oscilloscope waveform (S-curve) is symmetrical
between A and B. And confirm peak to peak level within 2 ± 1
Vp-p.
S-curve waveform
symmetry
BD board
TP (RFAC)
TP (VC)
+
–
Procedure:
1. Connect an oscilloscope to test point TP (RFAC) and TP (VC)
on the BD board.
2. Turn the power on.
3. Put the disc (YEDS-18) in to playback the number five track.
4. Confirm that oscilloscope waveform is clear and check RFAC
signal level is correct or not.
Note: A clear RFAC signal waveform means that the shape “◊” can be
clearly distinguished at the center of the waveform.
RFAC signal waveform
VOLT/DIV: 200 mV
TIME/DIV: 500 ns
A
within 2 ± 1 Vp-p
B
level: 1.0 ± 0.4 Vp-p
Note: • Try to measure several times to make sure than the ratio of A : B
or B : A is more than 10 : 7.
• Take sweep time as long as possible and light up the
brightness to obtain best waveform.
Checking Location: BD board (Side B)
RFDC Level Check
Connection:
oscilloscope
BD board
TP (RFDC)
TP (VC)
+
–
Procedure:
1. Connect an oscilloscope to test point TP (RFDC) and TP (VC)
on the BD board.
2. Turn the power on.
3. Put the disc (YEDS-18) in to playback the number five track.
4. Confirm that oscilloscope waveform is clear and check RFDC
signal level is correct or not.
Note: A clear RFDC signal waveform means that the shape “◊” can be
clearly distinguished at the center of the waveform.
28
Checking Location: BD board (Side B)
CX-BK1
E-F Balance Adjustment
Connection:
Checking Location:
– BD BOARD (Side B) –
oscilloscope
BD board
TP (TE)
TP (VC)
+
–
Procedure:
1. Connect an oscilloscpe to test point TP (TE) and TP (VC) on
the BD board.
2. AC is put in pushing B button to enter the CD test mode.
3. Put the disc (YEDS-18) in to playback the number five track.
4. Press the B button. If it plays, press the B button again.
(The tracking servo and the sledding servo are turned OFF)
5. Rotate RV101 on the BD board to adjust A (DC voltage) of
the center of the oscilloscope waveform becomes 0 V.
Traverse Waveform
IC101
RV101
E-F Balance
Adjustment
Center of
the waveform
TP7
(VC)
IC103
TP2
(TE) TP6
(RFDC)
TP8
(RFAC)
TP4
(FE)
B
A (DC
voltage)
0V
level: 1.0 ± 0.5 Vp-p
6.
Press the B button. (The tracking servo and sledding servo
are turned ON)
Confirm A (DC voltage) at that tome is 0 V.
7. To exit from this mode, turn the power off.
Notes: • Always move the optical pick-up to most inside track when
exiting from this mode. Otherwise, a disc will not be unloaded.
• Do not run the sled motor excessively, otherwise the gear can
be chipped.
Traverse Waveform
A (DC
voltage)
0V
Tracking servo
Sled servo
OFF
Tracking servo
Sled servo
ON
Checking Location: BD board (Side B)
Adjustment after CD Base Unit (BU-30CBD64NS) is Replaced
Perform the “E-F Balance (1 track jump) check”.
29
CX-BK1
MEMO
30
CX-BK1
SECTION 8
DIAGRAMS
8-1.
BLOCK DIAGRAM – CD Section –
• R-ch is omitted due to same as L-ch.
• SIGNAL PATH
OPTICAL PICK-UP
BLOCK
2
4
7
5
3
1
VC
RF AC 15
50 RFAC
6 A
RFDC 28
43 RFDC
7 B
RFDCI 29
27 VC
VCC
PD1
D OUT 64
I1-6
9 D
FE 16
10 E
FEI 17
11 F
AUTOMATIC
POWER CONTROL
Q101
PCMD 66
12 SDIO
BCLK 67
13 BCKIA
41 TE
LRCK 65
14 LRCKIA
40 SE
XTAI 71
39 FE
TE 18
PD
1 LD
XTAO 72
CD-L
LO 23
RO 26
A
(Page 32)
R-CH
X201
16.9344MHz
19 TE_BAL
SW 12
2 PD
62 XI
MOTOR/COIL DRIVE
IC102
63 XO
VR
SYSTEM CONTROLLER
IC901 (1/3)
MIDIO 5
F+
FT+
TRACKING
COIL
(AEP, UK)
RV101
E-F BALANCE
(1 TRACK JUMP)
FOCUS
COIL
DIGITAL
OPTICAL
OUT
D/A CONVERTER,
MP3 DECODER
IC104
8 C
I5-10
GND
: DIGITAL OUT
OPTICAL
TRANSCEIVER
IC604
VDD (3.3V)
PD2
LD
: CD
DIGITAL SERVO,
DIGITAL SIGNAL PROCESSOR
IC101
RF AMP
IC103
T-
M102
(SLED)
MICK 6
52 VO1+
IN1+ 35
33 FFDR
47 VO1-
IN1- 34
34 FRDR
56 VO2+
IN2+ 32
31 TFDR
55 VO2-
IN2- 31
32 TRDR
2 VO3+
IN3+ 27
29 SFDR
M
1 VO3-
STAND BY 19
IN3- 26
30 SRDR
STOCKER MOTOR DRIVE
IC721
64 IO-MIDIO
O-ELV_POS 75
7 FIN
OUT1 4
38 O-MP3STB
62 O-MICK
O-ELV_NEG 87
9 RIN
OUT2 2
MIACK 7
37 I-MIACK
RESET 1
19 O-MP3RST
MICS 3
5 O-MICS
REQ 39
65 I-MP3REQ
MILP 4
66 O-MILP
DATA 4
CLOK 6
52 O-DATA
XLAT 5
60 O-XLT
SQCK 77
57 O-SQCK
55 O-CLOCK
M101
(SPINDLE)
IN4R 24
M
5 VO4STBY
25 MDP
SCOR 15
21 I-SCOR
SQSO 76
56 I-SQSO
SENS 7
58 I-SENS
8
M761
(STOCKER)
M
M781
(ROLLER)
M
M771
(MODE)
ROLLER MOTOR DRIVE
IC711
O-LOD_NEG 85
7 FIN
OUT1 4
O-LOD_POS 77
9 RIN
OUT2 2
MODE MOTOR DRIVE
IC701
O-SLD_POS 76
O-SLD_NEG 86
7 FIN
OUT1 4
9 RIN
OUT2 2
S771
ROTARY ENCODER (MODE)
SCLK 8
10 VO4+
M
I-SLD_E0 88
1
I-SLD_E1 73
2
I-SLD_E2 89
3
I-SLD_E3 70
4
G
S702
ROTARY ENCODER
(STOCKER POSITION)
XRST 2
I-ELV_E0 90
1
I-ELV_E1 69
2
I-ELV_E2 67
3
I-ELV_E3 68
4
G
61 O-XRST
S711 (DISC INSERT(8/12cm))
49 O-PWM3
51 O-PWM2
I-SW1-A 82
S713 (DISC IN (8/12cm))
47 O-PWM1
59 O-LDON
I-SW2-A 79
S714 (DISC IN (8cm))
I-SW2-B 83
S715 (DISC OUT)
I-SW3 80
S718 (STOCKING)
S711 (ON : When disc insert)
S713 (ON : Play position)
S714
S715 (ON : When disc out from play position)
S718
OFF: In the Midst disc is moving
between play position and
stocker
S717
In the midst disc is moving
between play position and stocker
ON : disc is play position side
OFF : disc is stocker side
S716
ON : The moment disc in/out
from stocker
I-SW4 78
S717 (DISC POSITION)
I-SW5-A 84
S716 (STOCKER IN/OUT)
I-SW5-B 74
I-D_SENSOR 81
31
31
LEVEL SHIFT
Q731
ON : Play position
(8cm disc only)
DISC INSERT
DETECT SENSOR
IC751
CX-BK1
8-2.
BLOCK DIAGRAM – TUNER/TAPE/USB Section –
(Chilean, Peruvian, Mexican)
MIC LEVEL
AGC
Q201
• R-ch is omitted due to same as L-ch.
• SIGNAL PATH
VR201
MIC MIXING
J201
MIC
MIC AMP
IC201 (1/2)
: CD
: TUNER
MIC AMP
IC201 (2/2)
: TAPE PLAY
(Page 31)
A
: REC
: USB
CD-L
FM 75 Ω
(COAXIAL)
FM ANT
: AUX IN
: LINE IN (AUDIO)
2 MIC
TUNER-L
: VIDEO
40 CD-L
R-CH
TUNER-R
AM LOOP
: MIC
INPUT SELECT
IC601 (1/2)
FM/AM TUNER PACK
AM ANT
39 TUNER-L
DO
MDATA
MCLK
PLLCE
TUNED
STEREO
DO
DI
CLK
CE
TUNED
STEREO
B
(Page 33)
C
(Page 33)
D
(Page 33)
38 TAPE-L
37 AUX-L
35 RECB-2
RDS DATA
RDS CLK
RDS SIG
RDS DATA
RDS INT
FM SIGNAL OUT
OUT-L
TOUTL 29
(AEP, UK)
V-BASS,
18 – 24
MDATA, MCLK,
LEVEL
MUTING
Q309
R-CH
MDATA
MCLK
PB AMP
IC301
L-CH
R-CH
DO
MDATA
MCLK
PLLCE
TUNED
STEREO
R-CH
REC SWITCH
Q305 – 308
R-CH
MUTING
Q443
R-CH
SFR451
RECORD
BIAS (R)
RECORD
BIAS (L)
REC/PB
SFR452
JK602 (2/2)
R-CH
REC MUTE
R-CH
HRPE1
(REC/PB/ERASE)
REC AMP
IC401
LINE AMP
Q605
L
AUX OUT
R-CH
R
REC BIAS
SWITCH
Q451
+12V
SHIFT REGISTER
IC703
R-CH
ERASE
BIAS
Q608
BIAS OSC
Q453, 454
BIAS
REC MUTE
REC/PB
6 Q0
7 Q1
8 Q2
Q3
Q4
Q5
Q6
Q7
Q8
Q9
Q10
9
10
11
12
13
14
15
16
RDS-SIG
V-BASS
18
19
20
21
22
23
24
SO
DATA
CLOCK
LCK
JK603
VIDEO OUT
J701
LINE IN
SYSTEM CONTROLLER
IC901 (2/3)
6
50
48
46
9
8
I-DO
O-MDATA
O-MCLK
O-PLLCE
I-TUNE
I-STEREO
VIDEO
2 I-RDS_DATA
20 I-RDS_CLK
1 I-RDS SIG
USB VBUS
USB DATA
USB CLK
USB ACK
USB INT
33 I-USB_VBUS_ON
(EXCEPT US)
24
25
31
32
I2C-USB_DATA
I2-USB_CLK
I-USB_ACK
I-USB_INT
18 3 4 5
R-CH
14 X1
USB INTERFACE
IC700
12 X0
COM X 13
3
4 5
14 Q8
3
23 VBUS
1
2
20 21 13 12
X700
12MHz
R-CH
Q1 7
Q2 8
A B
10 9
Q11 17
SO 18
A
B
9 Q3
16 Q10
Q0 6
Q9 15
Q4 10
SHIFT REGISTER
IC701
32
32
I-DECK_ENDSW
I-DECK_PACK
I-DECK_FREC
I-DECK_RREC
I-DECK_PLAYSW
27
28
29
30
26
END SW
PACK
F_REC
R_REC
PLAY SW
(DECK-A)
CAPSTAN/REEL
MOTOR DRIVE
Q904
15 X2
A
B
USB ON/OFF
SWITCH
Q702
OUTL 5
OUTR 6
SDA
SCL
ACK
INT_DATA
1
36 FINL
39 FINR
USB DATA
USB CLK
USB ACK
USB INT
25 D –
FOUTL 34
FOUTR 37
XTO
VBAS
2
USB VBUS ON
D–
26 D+
XTI
D+
TAPE MECHANISM
DECK BLOCK
PLUNGER DRIVE
Q905
INH
SHIFT SO
USB ON
CD ON
TUNER ON
CLK
LCK
R
CLOCK
LCK
AUX IN
DATA
AUX AUDIO
SELECTOR
IC501
JK602 (1/2)
L
J700
(USB)
44 O-SHIFT_DATA
43 O-SHIFT_CLK
45 O-SHIFT_STB
R-CH
R
BAND-PASS
FILTER
Q902
(AEP, UK, Chilean, Peruvian)
L
AUDIO
I-LEVEL 99
(AEP, UK)
RDS-DATA
RDS-CLK
MUTING
Q607
BIAS OSC
L451
LEVEL
(EXCEPT US)
A-SOL
(CAPSTAN/REEL)
CAPM+
M
INH, SHIFT SO,
CLK, LCK
USB ON,
CD ON, TUNER ON
E
(Page 33)
F
(Page 34)
CX-BK1
8-3.
BLOCK DIAGRAM – AMP Section –
M301
(FAN)
SWITCHING
Q618
• R-ch is omitted due to same as L-ch.
• SIGNAL PATH
: TUNER
OUTPUT LEVEL
DETECT
Q620, 621
R-CH
SWITCHING
Q619
GIN
GOUT
OUTA 6
BBE
VREF
1 INA
7 14
13 12
28 VOLIN2
R-CH
PRE DRIVE
Q517
OUT 2 25
+
FEED BACK
SWITCH
Q625
– VH
OUTPUT LEVEL
DETECT
Q617, 622 – 624
MUTING
CONTROL
Q527
(Page 32)
C
D
+
BIAS
Q507, 509
R-CH
OVER LOAD
DETECT
Q505
OVER CURRENT
DETECT
Q013
R-CH
R-CH
RY501
+
–
L
+
–
R
TH501, 502
+
RELAY DRIVE
Q530
THERMAL
DETECT
Q610, 611
HOLD
Q012
J521
PHONES
+
D611
21
22
23
24
18
19
20
V-BASS
V-BASS,
18 –24
JK502
5 SPEAKER
FINAL DRIVE
Q531, 533
R-CH
BOOST
CONTROL
Q617 – 620
+
MDATA
MCLK
LEVEL
(Page 32)
R-CH
+
R-CH
21 22 19
FREQUENCY
CONTROL
Q614 – 616
CASCADE
Q511, 513, 515
MUTING
Q525
BB_A2 27
BB_B2 26
BOOST
CONTROL
Q624
BBE ON/OFF
CONTROL
Q623
FAN MOTOR
DRIVE
Q301 – 303
–VP
ELECTRICAL VOLUME
IC601 (2/2)
DATA
CLOCK
SAOUT
OUT-L
R-CH
– VL
CURRENT
MIRROR
Q521, 523
+VP
BASS BOOST ENHANCER
IC603
B
+
+VL
R-CH
(Page 32)
M
+VH
MDATA, MCLK,
LEVEL
THERMAL DETECT
X901
32.768kHz
X902
5MHz
15
98
XT1
XT2
X1
DATA
CLK
LCK
SO
6 – 15
Q0 – Q9
3
4
5
18
Q10 16
X2
I-POWER_MONI
I-POWER_DOWN 41
LED DRIVE
Q601 – 605
LED631 – 635
(DISC INDICATOR 1 – 5)
6 – 11
CLK
LCK
Q7 12
97 – 95
S311 – 320, 331 – 339,
S341 – 344
I-KEY1 – I-KEY3
VOLUME
ROTARY
ENCODER
S301
93 I-RE_VOL
BASS
ROTARY
ENCODER
S302
92 I-RE_BAS
TREBLE/MIDDLE
ROTARY
ENCODER
S303
91 I-RE_TRE
MULTI JOG
ROTARY
ENCODER
S304
94 I-RE_JOG
LED203
i-Bass
LED DRIVE
IC601
2 DATA
3 CLK
4 LCK
(Page 34)
J
(Page 34)
O-POWER 40
STBY
LED202
STANDBY/ON
LED DRIVE
IC602
SHIFT SO
CLK
LCK
H
SYSTEM CONTROLLER
IC901 (3/3)
OSC
Q1 – Q6
OSC 76
(Page 34)
I-HEADPHONE 42
RESET 16
INH
INH, SHIFT SO,
CLK, LCK
14
34
13, 14
E
18
INH 77
C105, R101
(Page 32)
17
53 O-LCD_DATA
54 O-LCD_CLK
63 O-LCD_CE
Q8, Q9
S1 – S65
1 – 65
67 – 70
COM1 – COM4
LIQUID CRYSTAL
DISPLAY
LCD001
DI 80
CL 79
CE 78
39
O-MUTE
POWER MONITOR
LCD DRIVER
IC001
G
POWER
LED204 – 221
(ILLUMINATION)
LED251 – 254
(LCD BACKLIGHT)
REMOTE CONTROL
RECEIVER
IC603
LED601
(DISC SLOT ILLUMINATION)
33
33
23 I-RMC
POWER_DOWN
RESET
CX-BK1
8-4.
BLOCK DIAGRAM – POWER SUPPLY Section –
+VH
(Page 33)
H
POWER,
POWER MONITOR
VOLTAGE
DETECT
Q107 – 109
POWER MONITOR
VCC 9V
AC DETECT
Q105, 106
+
DC UNBALANCE
DETECT
D139, 140
+
DC UNBALANCE
DETECT
D112, 113
+9V
REGULATOR
Q050, 051
+VL
POWER
USB 5V
(Page 32)
F
USB ON,
TUNER ON, CD ON
– VH
+5V
REGULATOR
IC701
RECT
D116, 117
+
– VL
RECT
D120, 121
OVER CURRENT
DETECT
Q102 – 104
B+ SWITCH
Q700, 701
RECT
D114, 115
USB ON
VM 10V
+10V
REGULATOR
IC101
TU 9V
+9V
REGULATOR
Q890
THERMAL DETECT
REGULATOR
CONTROL
Q891, 892
TUNER ON
G
(Page 33)
FAN B+
+12V
REGULATOR
IC003
M+12V,
VM, +12V
POWER TRANSFORMER
(MAIN)
PT001 (Mexican)
PT002 (Chilean, Peruvian)
PT003 (US, AEP, UK)
D002
(Chilean, Peruvian)
S001
VLOTAGE SELECTOR
120V
220 – 230V
VH
+VH
– VH
RECT
D004
VH
RECT
D002
VL
240V
(EXCEPT US)
+7V
REGULATOR
IC001
CD VM (7V),
+7V
FR VDD (3.3V)
SERVO
+2.5V
+2.5V
REGULATOR
IC121
VDD (3.3V)
VL
+VL
(US)
– VL
+3.3V
REGULATOR
Q018, 019
RY502
REG
REG
RECT
D007 – 010
B+ SWITCH
Q024, 025
(AC IN)
REG
(US, Chilean, Peruvian, Mexican)
RY001
CD ON
RELAY DRIVE
Q101
+12V
VSTBY
VDD
EVER 3.3V
(Page 33)
J
POWER_DOWN,
RESET
D902
B+ SWITCH
Q901, 906
VOLTAGE
DETECT
IC904
POWER_DOWN
RESET SIGNAL
GENERATOR
IC902
RESET
34
34
D906
+4V
REGULATOR
IC905
D612
POWER TRANSFORMER
(SUB)
PT005 (Chilean, Peruvian)
PT006 (EXCEPT Chilean, Peruvian)
RECT
D005, 006
EXCEPT
Chilean, Peruvian
CX-BK1
8-5.
• Circuit Boards Location
NOTE FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS
Note on Printed Wiring Boards:
• X : parts extracted from the component side.
• Y : parts extracted from the conductor side.
a
•
: Through hole.
f
: internal component.
•
•
: Pattern from the side which enables seeing.
(The other layers' patterns are not indicated.)
Caution:
Pattern face side:
(Side B)
Parts face side:
(Side A)
Note on Schematic Diagram:
• All capacitors are in µF unless otherwise noted. pF: µµF
50 WV or less are not indicated except for electrolytics
and tantalums.
• All resistors are in Ω and 1/4 W or less unless otherwise
specified.
f
: internal component.
•
• 2 : nonflammable resistor.
• C : panel designation.
Parts on the pattern face side seen from
the pattern face are indicated.
Parts on the parts face side seen from
the parts face are indicated.
tuner unit
main board
speaker board
Note: The components identified by mark 0 or dotted line
with mark 0 are critical for safety.
Replace only with part number specified.
•
•
•
•
•
•
•
•
A : B+ Line.
B : B– Line.
H : adjustment for repair.
Voltages and waveforms are dc with respect to ground
under no-signal (detuned) conditions.
– BD Board –
no mark : CD PLAY
– DECK Board –
no mark : TAPE PLAY
(
) : TAPE REC
– USB AUX Board –
no mark : USB
– Other Board –
no mark : TUNER
(
) : CD PLAY
〈〈
〉〉 : TAPE PLAY
{
} : TAPE REC
[
] : USB
: Impossible to measure
∗
Voltages are taken with a VOM (Input impedance 10 MΩ).
Voltage variations may be noted due to normal production tolerances.
Waveforms are taken with a oscilloscope.
Voltage variations may be noted due to normal production tolerances.
Circled numbers refer to waveforms.
Signal path.
F : TUNER
J : CD
c : DIGITAL OUT
E : TAPE PLAY
d : USB
j : REC
N : MIC
G : AUX IN
q : LINE IN (AUDIO)
r : VIDEO
Abbreviation
E51 : Chiliean and Peruvian models
MX : Mexican model
AMP board
ACDC board
PT board
SW (2) board
deck board (EXCEPT US)
SW (1) board
SW (3) board
right button (1) board
speaker motor board
left button board
LCD VOL board
SW (4) board
key LED RMC board
roller motor board
connector board
USB AUX board
BD board
jog board
LED board
mode motor board
right button (2) board
MIC board
35
35
headphone board
CX-BK1
8-6.
• Semiconductor
Location
1
2
• See page 35 for Circuit Boards Location.
3
:Uses unleaded solder.
4
5
6
7
Location
B-6
C-6
C-5
B-5
C-5
Q101
C-3
A
C272
B
IC104
IC101
IC121
IC101
IC102
IC103
IC104
IC121
R284
Ref. No.
PRINTED WIRING BOARD – BD Board –
A
TP2(TE)
C
CN507
(Page 43)
TP6(RFDC)
TP8(RFAC)
TP7(VC)
IC102
E
IC103
D
A-MAX. 3
36
36
B
TP4(FE)
(Page 43)
CX-BK1
8-7.
SCHEMATIC DIAGRAM – BD Board –
• See page 42 for Waveforms.
• See page 68 for IC Block Diagrams.
C203
1000p
R216
1M
C269
47 4V
TP9
CKO
FB102
0
R251 220
C256 0.1
C257 0.33
C270 220p
R275 10k
R272 4.7k
C271 0.01
C274 0.01
FB104
0
R271
10k
C255
0.1
C249
0.1
R250 220
C259
0.1
C263
47 4V
R284
220p
R279 100
R255 100
R257 100
R276 100
R259 100
C292
0.1
D/A CONVERTER,
MP3 DECODER
IC104
TC94A20F-CX4
FB291
0
C266
0.1
C250
0.1
R111 150k
C116 0.1
B
TP5
RFACI
C213 3300p
R104
15k
TP2 TE
R102 15k
TP8
RFAC
C107 R120
33p 120k
CN101
16P
C112 0.1
R105 1k
R126 39k
R260
1k
FB103
0
C261
220
4V
R351 0
MAIN
BOARD
(4/4)
CN507
FB351
C102
0.1 B
CXA2647N
RV101
47k
R117
120k
E-F Balance
(1Track Jump)
R114
390k
R101
0
C118
1
R113
2.4k
TP6
RFDC
C119
1
C114
1000p
C110
0.1 B
A-MAX. 3
Q101
2SB970
C253
0.1
C115
100 10V
R266
R265 220
220
C251
0.1 C264
47
4V
C265
47
4V
TP7
VC
C117
0.1
FB203
0
R133 2.2k
TP3 SE
C111
47 4V
R122
100k
C108
0.1
C113
100
10V
R123
3.3
R118
10k
R132 330k
C268
4700p
C267 4700p
0
R115
33k
IC103
C103
470p
C224
1
R202 10k
R204 3.3k
R205 1k
R207 1M
R206
4.7k
R116
33k
R199
0
A
R261
0.1
C209 100p
C211
0.1
R303
0
R203 100k
R308
0
CN104
11P
C216
0.01
C212
1500p
R201 33k
C230
0.1
C226
47 4V
C109 0.1
R125 39k
C313
0.1
C310
0.1
C104
3300p
C215
0.47
B
R103
100k
C101
470p
R313 0
C272
0
R131 68k
C133
2.2
TP4 FE
(Page 47)
R230 150
R231 330
M102
C131
0.068
C132 0.022
R232 330
R233 330
C227
0.1
C121 0
R168 1k
DIGITAL SERVO,
DIGITAL SIGNAL PROCESSOR
R252
1M
R169 0
IC101
CXD3068Q
R253
1k
C222
0.1
R219
1k
R309
0
R221 100
R222 100
R220 1k
R223 100
R224 100
C151
0.1
C314
1
L101
R311
0
C260
100
6.3V
C231
1000
6.3V
C229
0.1
IC102
C208
0.1
AN41020A
R318 0
R225 100
C205
0.1
C202
0.1
R226 100
R227 100
C273 220p
(Page 44)
IC121
BA25BCOFP-E2
R218 1k
B
MAIN
BOARD
(1/4)
CN902
FB201
0
R249 560
R163 10k
C254 22p
C258 22p
R167 0
R162 10k
X201 16.9344MHz
FB204
0
C122 0.1
M101
R166 1k
R310 0
C316 0.1
R291 0
CN102
23P
R316
0
R321
0
R319
0
C152
0.1
C153
0.1
R155
0
R314 0
TP1
SP
R151
100k
FB161
BLM21P331
C150
220 10V
C156
0.01
L163
0
C169
220 10V
R152 2.2k
The components identified by mark 0 or dotted
line with mark 0 are critical for safety.
Replace only with part number specified.
37
37
CX-BK1
8-8.
PRINTED WIRING BOARDS – CHANGER Section – • See page 35 for Circuit Boards Location.
1
2
3
4
:Uses unleaded solder.
5
6
7
9
8
A
SW (1) BOARD
(Page 43)
C
SW (2) BOARD
B
C
IC701
IC751
IC721
IC711
D
SW (3) BOARD
S718 (STOCKING)
SW (4) BOARD
OFF: In the Midst disc is moving
between play position and
stocker
S717 (DISC POSITION)
In the midst disc is moving
between play position and stocker
ON : disc is play position side
OFF : disc is stocker side
E
S716 (STOCKER IN/OUT)
ON:The moment disc in/out
from stocker
• Semiconductor
Location
Ref. No.
Location
D701
D711
D721
C-4
C-4
C-4
IC701
IC711
IC721
IC751
C-4
D-4
C-4
C-2
Q731
B-5
38
38
CX-BK1
SCHEMATIC DIAGRAM – CHANGER Section –
CN751
3P
1
DIODE
IC751
• See page 68 for IC Block Diagram.
CN702
3P
1
D SENSE
R731
100
DIODE
D SENSE
GND
R733
10k
GND
3
GND
RIN
VCC
FIN
OUT1
VM
OUT2
D+3.3V
3.2
R732
1k
VREF
3
RNF
DETECT SENSOR
IC751
RPR-220
CN701
27P
R734
12k
DISC INSERT
M+12V
Q731
RT1N141
M+12V
LEVEL
MGND
MODE MOTOR
DRIVE
SHIFT
MGND
D.SENSOR
IC701
BA6956AN
C754
0.1
C711
10
50V
C758
0.1
R701
680
D701
MTZJ-T-77-4.7B
SW2A
SW2-A
SW2B
SW2-B
C751
0.1
SW5B
SW5-B
SW5A
SW5-A
MTR RL 2
C781
0.01
SLD (MD) NEG
RIN
GND
VCC
FIN
VM
2
RNF
VREF
2
OUT1
LOD (ROL) NEG
MTR RL 1
MTR RL 1
-
OUT2
+
M781
(ROLLER)
C
SLD (MD) POS
CN703
2P
1
SW3
SW1-A
C756
0.1
C752
0.1
CN781
2P
1
MTR RL 2
SW3
SW1
C755
0.1
R702
100
LOD (ROL) POS
ROLLER MOTOR
ELV POS
MAIN BOARD
(1/4)
CN901
(Page 44)
DRIVE
ELV NEG
SW4
GND
RIN
VCC
FIN
VM
RNF
OUT1
VREF
SW4
OUT2
8-9.
IC711
BA6956AN
C753
0.1
STOCKER MOTOR
P02 SLD E1
R712
100
DRIVE
SLD E2
IC721
BA6956AN
+
M761
(STOCKER)
CN761
2P
1
MTR ST 2
CN704
2P
1
MTR ST 2
C761 R722
0.01
100
SLD E3
C765
0.1
D711
MTZJ-T-77-5.6B
R711
680
ELV E0
ELV E1
C764
0.1
ELV E2
C763
0.1
MTR ST 1
MTR ST 1
SLD E0
ELV E3
2
C762
0.1
2
D721
MTZJ-T-77-3.6A
R721
680
S702
ROTARY ENCODER
(STOCKER POSITION)
CN711
2P
1
CN705
2P
1
GND
GND
SW1
S711
SW1
SW1
2
2
CN721
3P
1
1
(DISC INSERT(8/12cm))
(ON:WHEN DISC INSERT)
GND
S713
CN706
3P
GND
SW2-A
SW2-A
SW2A
SW2-B
SW2-B
SW2B
(DISC IN(8/12cm))
3
(ON:PLAY POSITION)
3
S714
(DISC IN(8cm))
(ON:PLAY POSITION(8cm DISC ONLY))
S771
ROTARY ENCODER
(MODE)
CN731
2P
1
GND
CN707
2P
1
SW3
S715
SW3
SW3
2
CN710
7P
1
E1
C769
0.1
GND
E2
C768
0.1
C767 0.1
E3
C766 0.1
E4
E1
E2
GND
2
(DISC OUT)
CN771
7P
1
GND
E3
(ON:WHEN DISC OUT FROM PLAY POSITION)
E4
MTR MD 1
MTR MD 1
MTR MD 2
CN741
4P
1
GND
S716
(STOCKER IN/OUT)
CN708
4P
1
C771
0.01
GND
SW5-B
SW5-B
SW5B
SW5-A
SW5-A
SW5A
SW4
SW4
SW4
ON:THE MOMENT DISC IN/OUT
FROM STOCKER
4
4
S717
(DISC POSITION)
IN THE MIDST DISC IS MOVING
BETWEEN PLAY POSITION AND STOCKER
ON:DISC IS PLAY POSITION SIDE
OFF:DISC IS STOCKER SIDE
S718
(STOCKING)
OFF:IN THE MIDST DISC IS MOVING
BETWEEN PLAY POSITION AND STOCKER
39
39
MTR MD 2
7
7
+
M771
-
(MODE)
CX-BK1
8-10. PRINTED WIRING BOARD – DECK Board (Except US model) –
• Semiconductor
Location
2
3
4
5
:Uses unleaded solder.
6
7
8
9
Location
C459
JR402
JW304
R454
JR320
R410
SFR451
R406
JW307
C411
C406
R465
R375
R466
C315
R405
JW312
R376
C461
JW314
C317
R409
D
R407
(CHASSIS)
C325
C405
IC401
C408
5
4
G
D
R423 JR322
R419
E
R416
R414
Q443
R425
R399
R421
C327
R422
R418 E
Q444
R420
C410
D
C399 S
G
D
1
R303 JR318
E
C303
Q309
E
Q310
R424 Q308
D401
S
R307
R304
R316
C326
C309
C304
4
1
R-CH
40
8
R314
F
G
1
5
8
8
L-CH
R318
IC301
R317
JR304
JR319
R310
JW306
R315
R308
40
R306
R313
JR321
S
R417
E
JR302
R319
G
C409
C308
R309
JR303
C313
E
Q307
R413
1
C318
JR401
R415
R411
R412
8
C407
C307
R305
C462
Q306
(Page 43)
R322
JW308
R403
EP301
MAIN
BOARD
CN009
FB301
R321
SFR452
C413
C403
JW303
D
R401
R408
E
R457
R459
C401
C460
R456 C454
Q454
R404
Q451
JW302
C455
JW317
C
JW305
JW301
E
C458
E
C404
R453
C360
B
CN008
R458
R460
C412
C452
C456
C457
C402
C453
Q453
R455
R323
L451
BIAS OSC
CN302
E-4
D-5
E-4
F-4
E-5
E-5
E-3
F-3
B-6
B-5
B-5
DECK BOARD
JW309
Q305
Q306
Q307
Q308
Q309
Q310
Q443
Q444
Q451
Q453
Q454
A
JW310
E-7
E-3
Q305
IC301
IC401
JW315
F-3
JW316
D401
R402
Ref. No.
1
• See page 35 for Circuit Boards Location.
ERASE
C310
12
C314
1-688-685-
(12)
CX-BK1
8-11. SCHEMATIC DIAGRAM – DECK Board (Except US model) –
• See page 42 for Waveforms.
R321
0
CN008
11P
1
C317
0.1
50V
R376
1k
R317
1.2k
R306
3.9k
3
8
C309
47p
2
JR303
0
R307
470
IC301(1/2)
NJM14558M
TE2
R315
390k
PB-L
R313
18k
REC-L
C313
0.0068
R303
82k
R309
56
PB-R
C307
100
10V
REC-R
PB AMP
A-GND
C303
0.0012
REC/PB SW
C308
100
10V
VM_A
R375
1.2k
REC-MUTE
(Page 46)
C315
220
16V
R314
18k
O-BIAS
C314
0.0068
R304
82k
R305
220k
R310
56
C304
0.0012
R323
100
DECK-D-GND
R318
1.2k
+12V
R316
390k
6
7
R322
0
IC301(2/2)
NJM14558M
TE2
C318
0.1
50V
C401
0.1
50V
JR304
0
C413
0.1
HRPE301
3
R419
1k
8
R403
1k
2
R405
47k
R407
1k
C405
0.01
C406
0.01
R409
1.2k
(REC/PB/ERASE)
R423
18k
CN302
8P
1
IC401(1/2)
NJM14558M
TE2
C403
82p
R308
470
4
C360
220
16V
C326
0.022
R401
120k
C310
47p
5
Q443
2SA1362G
R413
2.2k
R411
15k
MUTING
R415
680
C411
10
50V
C407
0.01
C412
10
50V
C408
0.01
ERASE
R421
22k
Q307
2SJ460
C327
0.1
C409
0.0047
L-CH
Q305
2SJ460
S
C399
470p
R425
10k
R417
10k
R422
22k
S
R319
4.7k
R399
1M
Q309
2SA1362G
C410
0.0047
R-CH
MUTING
C404
82p
R406
47k
R408
1k
R410
1.2k
R416
680
REC AMP
Q305-308
D401
1SS355
R412
15k
C402
0.1
50V
6
R402
120k
7
R404
1k
5
4
FB301
0
REC SWITCH
S
R418
10k
Q308
2SJ460
Q310
2SA1362G
Q306
KRC104
S
R414
2.2k
IC401(2/2)
NJM14558M
TE2
Q444
2SA1362G
R420
1k
MUTING
R424
18k
MUTING
JR401
0
C461
390p
C462
390p
R465 100K
L451
BIAS OSC
R458
100k
C453
0.0027
R455
18k
SFR451
33K
C456
0.01
C455
0.0027
Q451
2SA1981
Y
Q453
KTC3198GR
REC BIAS
R460
33
BIAS OSC
C454
0.0027
C460
0.1
R453
3.3k
R466
100K
C459
560p
Q453,454
SWITCH
R457
15
R459
15
R456
18k
Q454
KTC3198GR
SFR452
33K
C458
0.001
R454
8.2
C452
22
25V
C325
0.1
C457
0.0056
EP301
(CHASSIS)
41
41
CX-BK1
• Waveforms
– BD Board –
– DECK Board –
– MAIN Board –
– USB AUX Board –
1 IC103 qg (RFAC) (CD play mode)
qa Q453, 454 Base (REC mode)
wa IC901 qg (X2)
ea IC700 2 (XTO) (USB mode)
1.2 Vp-p
3.6 Vp-p
qs Q453, 454 Collector (REC mode)
3.9 Vp-p
59.1 ns
37 Vp-p
200 ns
11.2 µs
2 IC101 us (XTAO)
2.4 Vp-p
84 ns
ws IC901 qk (XT2)
2.5 Vp-p
10.9 Vp-p
– LCD VOL Board –
30.4 µs
11.4 µs
ra IC001 uh (OSC)
qd Q453, 454 Emitter (REC mode)
0.9 Vp-p
1.5 Vp-p
21.5 µs
5.7 µS
42
42
CX-BK1
5
6
7
8
9
(Page 48)
FM/AM/TUNER PACK
SUPPLIED WITH THE
ASSEMBLED BLOCK
(Page 50)
F
JW990
R931
JW901
JW065
A
JW563
BD BOARD
CN104
JW562
JW069
JW981
B
BD BOARD
CN102
C939
(Page 36)
C940
Q018
(Page 36)
JW952
JW954
C928
R943
JW987
R945
R946
R944
C963
JW934
R914
JW989
JW933
(Page 38)
JW063
C014
R019
C017
43
JW938
R922
JW937
CN901
R912
C
D015
R038
R919
R917
R910
R921
JR907
C958
JR905
C962
C960
12
JW007
R017
Q019
R016
D016
R018
JW973
1-688-416-
JW006
JW003
JW004
E
E
JR904
R995
JW932
R904
J
R032
D017
R721
R719
JW991
R907
JW931
R902
ACDC
BOARD
CN004
JW062
JW015
Q024
R738 JW929
JW922
JW926
R963
JW073
C018
JW935
R925
E
C019
R718
R915
R909
E
JW074
R716
R920
JW936 R911
CONNECTOR
BOARD
CN701
R031
JW939
R717
R905
R941
JW071
K
JW994
JW993
R749
R913
C20
J
C961
R741
JW070
JW072
R723
R752
I
(Page 62)
R731
R733
AMP BOARD
CN006
(Page 54)
R713
C948
R901
R929
R712
R730
C959
R939
R938
R770
R773
JR908
R711
R708
R903
(AEP, UK)
R707
R734
CN902
R927 R923
Q25
JW976
JW957
Q901
JW943
JW942
JW924
JW925
JW921
R746
R936
R942
R932
R928
R930
R934
R926
C945 R924
JW020
JW561
JW955
JW953
IC902
JW920
JW918
JW919
JW902
R732
JW537
JW535
C909
JW986
JW985
JW984
JW916
JW917
R950
R940
JW546
JW536
I
JW980
JW045
JW941
C957
R787
R768
R983
JW075
C790
C791
R755
JW038
JW035
JW034
R051
JW031
JW903
R715 R722
R639
R918
JW008
IC701
R709
R703
JW930
R916
JW043
R759
R714
R710
R906
R908
JW547
JW550
R778
R724
C949
R740
R704
JW904
11
51
50
R737
R937
JW017
JW033
JW545
R780
10
R050
R003
JW992
JW997
CN009
JW050
JW051
JW048
JW049
JW044
JW803
JW047
R786
R784
JW052
R779
Q050
IC101 Q051
R052
R753
R745
20 JR701
1
E
R725
R751
JW940
R747
C908
R744
JW711
R726
C921
C920
R739
JW709
R756
JW717
R053
81
80
31
C956
C946
R781
JW712 C702
R766
R727
C955
43
K-3
K-3
J-3
G-4
G-6
B-5
D-2
F-6
E-3
C-6
D-9
E-8
D-8
D-8
C-9
D-8
E-8
IC101
IC501
IC601
IC603
IC604
IC701
IC703
IC901
IC902
IC904
IC905
G-5
B-5
D-3
D-5
G-2
G-7
E-7
F-9
E-8
E-8
D-9
Q25
Q018
Q019
Q024
Q050
Q051
Q602
Q604
Q605
Q607
Q608
Q614
Q615
Q616
Q617
Q618
Q619
Q620
Q623
Q624
Q625
Q890
Q891
Q892
Q901
Q902
Q904
Q905
Q906
I-2
K-3
K-3
J-2
G-6
G-6
E-3
F-2
F-2
F-2
F-2
E-5
F-5
E-4
D-5
E-5
E-5
E-5
E-5
E-5
E-5
D-6
D-6
C-6
D-9
C-10
C-9
C-9
E-8
C912
R764
R729
R750
JW710
D050
C918
R762
30
C950
JW905
R774
C917
C919
100
JR903
C951
R761
R935
CN507
1
JW951
JW032
JW651
CN508
R962
JW039
JW026
JW030
JW027
JW028
JW016
JW029
R765
C050
JW551
R981
JW802
R890
JW057
JW042
JW041
JW012
JW505
JW523
JW011
JW022
1
JW552
C016
JW540
JW541
JW542
JW543
3
C011
C007
C906
JW906
R772
C954
R760
C916
X901 R999 R998
R771
R623
R702
R701
1
JW907
C052
C012
C925
R996
C922
C915
JW962
R728
JW909
JW908
R520
C913
(EXCEPT US)
JW960
IC901
R954
JW910
R982
CN006
JW538
R021
JW549
H
JW560
JW558
6
JW061
JW559
JW534
JW557
3
C668
R011
C943
C923
C926
R628
R624
JW979
C952
R947
JW911
JW053
JW556
R020
(AEP, UK)
JW056
1
E
JW019
D018
JW533
JW060
2
C905
(EXCEPT US)
X902
R997
JW944
JW055
JW024
JW058
C669
IC6041
C637
R953
C927
R951
R952
JW958
E
R969
C911
JW978
JR906
JW959
C901
C910
R769
R767
JW021
R607
1
D911
JW915
JW025
JW059
DIGITAL
OPTICAL
OUT
4
3
JW977
JW975
C944
JW956 Q906
5
JW913
JW914
E
1
4
JW912
(FOR CHECK)
D902
JW945
JW054
Q608
C015
G
JW713
CN007
JW009
VIDEO OUT
R968
C792
JR704
JW548
3
R970
R960
R967
D904 C924
1
C013
E
IC904
JW037
IC703
C700
JW067
R636
R789
20
JW714
JR703
JR705
D905
D906
C932 R980
JW947
R788
JW707
JW708
JW040
R659
R782
R684
D
D
JW948
10
JW023
R643
JR607
JR602
C894
Q890
R688
R678
JR709
CN999
R961
C931
D910
C933
JR902 JR901
JR708
R959
C934
C953
R984
C930
E
Location
D015
D016
D017
D018
D050
D501
D611
D612
D613
D861
D902
D904
D905
D906
D907
D910
D911
R958
C935
JW949
JW946
S
4
C914
JW950
JR702
11
C936 3
JW706
JR706
JR707
JW544
JK603
(AEP, UK)
JW801
JW554
B5
R686
JR620
R660
(AEP, UK) JW704
R677
JW018
JW064
C639
(EXCEPT AEP, UK)
R513
C882
S
Q620
JW703
Q618
S
G
D
Q615
JW532
JW529
JW530
JW528
JW514
JW527
JW531
C643
R635
C654
C661
C645
R668
G
R863
JW553
JW650
JW649
C606
R663
R657
D
JW702
E
5
R955
R957
JW966
JW967
JW715
JW701
IC905 1
SUPPLIED WITH THE
ASSEMBLED BLOCK
R956
Q902
JW968
JW805
D612
JW511
E
R664
D
Q619
R640
R694
JW513
R645
L
Q624
D C697
R696
JW512
R651
R662
R606 R671
R641 R697 R695
Q605
S
G
Q614
R658
JR617
JR608
Q625
S
S
G
C638
G
JW066
JW644
JW627
JW638
R648
R647
R649
C614
E R642 JW626
Q616
E R646
C615
R652
AUX OUT
Q602
R689
C696 G
JW601
R644
R650
C694
R
R666
R888
C892
JW988
R992 R991
JW969
JW971
TAPE MECHANISM
DECK BLOCK
R763
Q904 R989
JW970
R879
JW705
R672
R687
E C675
JW625
JR614
R680
R679
JW555
Q617
C640
JR621
E
JW633
C657
R670
JW632
C641
JW614
D613
C610
E
Q604
R601
JW648
R602
R603
JK602
Q607
L
JW647
R604 C672
Q623
JW631
R629
JW603
R605
AUX IN
JW613
JW641
JW619
R
JW630
JW616
11
C677
E
C629
R655
C636
JW637
10
R667
R621
JR611
R622
R620
R683
R669
JR615
C635
JW617
JW620
R619
JW612
C631
C632
JW629
JW646
C662
C693
JR613
JR610
R986
C938
JW722
R682
E
R529
JW972
R891
E
E
C687
E R990
Q905
R987
JW974
R881
C685
JW628
JW611
R988
JW046
Q891
20
R681
JR612
R665
1
22
C656
R530
R531
R892
R895 R896
H
LCD VOL
BOARD
CN001
CN903
JW982 D907
C883
C684
C683
R656
C655 21
C663
C676
JW610
JW618
Q892
C682
IC603
C625
C627
(EXCEPT US)
(EXCEPT AEP, UK)
R893
JW804
R894
E
R785
JW639
C617
C630
C867
(Page 60)
JW963
JW964
R985
CN509
C866
CN504
R617
IC601
C628
C686
JW965
JW996
C872
R884
D861
R625
C626
E
R676
R614
JW608
JW609
R693
C621
R626
C634
D
JW622
C664
JW983
C692
JW995
JR801
CN905
JW645
JR802
JW502
JW961
R528
JW652
(AEP, UK)
JR502
JW621
R698 C611
C633
R675
D611
R674
R699
R887
R511
C507
CN506
R615
42
C873
C477
(AEP, UK)
R527
CN004
(EXCEPT US)
R885
JW643
R783
JW640
JW615
1
R630
C653
C603
R618
C622
R613
JW604
JW602
IC501
R526
(EXCEPT US)
JW606
R692
C604
8
∗CN508 15PIN CONNECTOR (AEP, UK)
CN509 11PIN CONNECTOR (EXCEPT AEP, UK)
R525
R521
9
R514
R523
R880 C876
C665
JR601
C613
C619
C618
C666
(EXCEPT US)
C624
R616
C602
JR624
(E51, MX)
JW526
JR503
R509
C623
R627
C607
(US, AEP, UK)
C515
C691
C503
R515
16 C517
JW525
1
C508
C501
R609
C601
C608
R612
C
C502
R510
R610
R522
JW607
JW605
R524
CN502
F
D501
R685
B
C504
JW501
R517
MAIN BOARD
C519
R516
JR501
R512
E
C518
JW522
AMP BOARD
CN502
JW036
(Page 54)
• Semiconductor
Location
Ref. No.
DECK BOARD
CN008
D
R933
MIC BOARD
CN205
11
AM LOOP
JW923
A
10
(Page 40)
USB AUX
BOARD
CN701
G
FM 75Ω
(COAXIAL)
L901
4
R748
3
JW928
2
:Uses unleaded solder.
JW927
1
• See page 35 for Circuit Boards Location.
R754
8-12. PRINTED WIRING BOARD – MAIN Board –
(12)
CX-BK1
8-13. SCHEMATIC DIAGRAM – MAIN Board (1/4) –
• See page 42 for Waveforms.
• See page 68 for IC Block Diagram.
(1/4)
CN901
27P
M23
F8
P2
B5
B4
D1
D2
R704 1k
R703 1k
R737 2.2k
C16
C20
C18
R732 2.2k
C19
R738 1k
R733 1k
R734 1k
R754 1k
C15
C17
C13
C14
R960
220k
F4
MDATA
F5
MCLOCK
C961 0.001
R914 100
M10
R915 100
M9
F6
LOD_NEG
R724 1k
O-LOD_NEG
SW3
M1
R922 47k
M12
R725 1k
M14
R726 1k
M16
R727 10k
M18
R728 10k
M20
R729 10k
O-DATA
P1
R745 1k
C939
0.1
O-PWM1
M-GND
K4
R760 2.7k
I-RE_BAS
I-RE_VOL
C918 1200p
I-RE_JOG
C917 1200p
K3
D-GND
I-KEY3
C916 0.0022
K2
(AEP,UK)
C915 0.0022
R749 1k
S2
T1
A-GND
IC901
µPD703260YGF-S04
-JBT-A
RDS-CLK
TU-SIG(ECHO_CE)
T4
F6
STEREO
O-POWER
T5
F7
R753 1k
TUNED
O-MUTE
R750 1k
D3
T6
R739 1k
D4
T7
CE
O-MP3STB(I2C_CLK)
DO
I-MIACK(I2C_DATA)
EVDD
S1
I-KEY2
EVSS
I-KEY1
STBY
O-SHIFT_STB
R932 100
C14
R933 100
C15
R934 100
C16
R935 100
C17
R936 100
C18
I-DECK_PLAYSW
C946 100p
C908 0.001
I-RMC
CAN'T USE
I-RDS_CLK
I-SCOR
O-MP3RST
XT2
XT1
RESET
X1
X2
VSS
REGC
R983
100k
U2
FR-GND
U1
R998 4.7M
L901
0
FR-VDD(3.3V)
A1
R953 100k
XRST
R996
C952
100p
DATA
C943
0.001
∗
X902
5MHz
C926
0.001
A9
∗
A8
R954
10k
R997
A5
R947
1k
A6
MOTOR
R952 100k
A2
S1
C13
C957 100p
C921
1
S3
R931 100
U3
I-USB_ACK
(Page 46)
O-SHIFT_DATA
C920
1
SOL
S2
PWM1
R943
0
C956 100p
I-USB_INT
O-SHIFT_CLK
C7
U4
+12V
A7
C12
R944
10k
R999 330k
C11
PWM2
R520
470k
T3
PWM3
C955 100p
I-USB_VBUS_ON
S3
∗ R997
0 (AEP, UK)
10k (US, E51, MX)
X901
32.768KHz
(EXCEPT US)
C10
S2
R982
100k
V-STBY
T7
(AEP, UK)
MP3STB
DGND
C9
U5
R995
10k (US, E51, MX)
1M (AEP, UK)
T1
R942 68k
R940 2.7k
R941 150k
R946
0
MICK
VDD
C9
C909
1800p
∗
FLMD0
R930 100
R945
I-TUNE
C8
MIACK
T5
C7
R929 100
MIDIO
T4
C6
R928 100
MP3RST
C954
0.0039
AVREF1
C5
R927 100
MP3REQ
R702
47k
I-DO
R926 100
I-SUFIX
O-MICS
C4
R701
220k
F10
AVSS
R925 100
P2
C3
P3
C2
R924 100
P1
R923 100
MICS
I-STEREO
I-LEVEL
D-GND
I2-USB_CLK
I2C-USB_DATA
I-POWER_MONI
F8
MILP
RDS-DATA
T2
I-POWER_DOWN
B7
C913 1200p
C945
0.1
HEADPHONE
O-POWER-MONITOR
K1
JR908
0
D-OUT
F10
F9
T2
CD_D-OUT
S3
T3
I-DECK_RREC
R762 2.7k
I-DECK FREC
R764 2.7k
K5
SYSTEM CONTROLLER
I-DECK_PACK
K6
S1
R748 1k
I-HEADPHONE
I-DECK_ENDSW
I-RE_TRE
C919 1200p
R747 1k
F9
AVREF0
R766 2.7k
K7
C912 1200p
R967
100
T6
O-SHIFT_CLK
I-ELV_E0
I_RDS _DATA
D+5V
R958
39k
R744 1k
O-SHIFT_DATA
I-SLD_E2
C940
1000
16V
M+12V
R957
0
O-PLLCE
I-SLD_E0
M+12V
FILTER
C928
22
50V
P3
O-SHIFT_STB
(ECHO_CE) I_RDS _SIG
MGND
BAND-PASS
F5
O-MCLK
O-ELV_NEG
MGND
Q902
2SC3052F-T
1-LF
O-PWM3
O-SLD_NEG
D.SENSOR
O-MDATA
MUTE
LEVEL
C930
0.001
O-LCD_CLK
I-CLOCK
O-XRST
O-MICK
O-LCD_CE
IO-MIDIO
BVSS
I-SW5-A
F4
R746 1k
POWER
F7
B2
M10
R959
1.5k
O-PWM2
C938
1
50V
B1
R921 47k
SW1-A
O-LCD_DATA
M2
I-SW2-B
I-SQSO(MUTE_REQ)
R714 10k
I-SENS(4CH _CLK)
R722 10k
M8
I-SQCK(SYS_RESET)
M6
R919 47k
SW2-A
O-LDON(4CH_DATA1)
R918 47k
O-XLT(4CH_DATA2)
M5
M3
O-MP3REQ
I-SW1-A
SW2-B
O-MILP
SENSOR
I-LEV_E2
R721 10k
I-ELV_E3
M3
I-ELV_E1
R917 2.2k
I-SLD_E3
M6
BVDD
I-D_
I-SLD_E1
R719 10k
I-SW5-B
M1
O-ELV_POS
R916 47k
O-SLD_POS
M7
I-SW4
SW5-A
O-LOD_POS
I-SW3
C963 0.001
M8
SW4
I-SW2-A
C962 0.001
LOD_POS
(Page 37)
R970
0
C960 0.001
SLD_POS
(Page 45)
C4
R955
1k
C959 0.001
SLD_NEG
(Page 47)
R961
4.7k
C958 0.001
ELV_POS
(Page 39)
R730 1k
M11
R752 2.2k
R913 100
C8
M12
R731 2.2k
R912 100
R909 47k
C6
M13
R639 1k
M14
R911 100
R741 1k
R910 100
ELV_NEG
R707 10k
SW5-B
R751 100
SLD_E0
R723 1k
SLD_E1
R712 1k
SLD_E2
C948
100p
R950
0
R740 1k
M22
C949
100p
C2
M21
M23
M7
R716 10k
R708 10k
M2
M5
R718 10k
R717 10k
M19
R908 47k
R710 10k
R907 47k
M15
R709 10k
R906 47k
M16
M17
R905 47k
M17
R711 10k
M18
SLD_E3
M13
R904 47k
M15
M19
R920
10k
R715 10k
R903 47k
M11
R902 47k
M20
ELV_E0
R713 1k
R901 47k
ELV_E1
M9
M22
M21
ELV_E2
B6
ELV_E3
VM_D
C951
100p
C950
100p
C906
0.001
C927
10
50V
C905
0.001
R951
10k
C1
C944
0.001
C5
CLOK
C924
0.22F
50V
C923
1
C910
18p
C922
0.1
C911
22p
XLT
CN999
7P
LDON
C3
C20
RESET
∗ R996
C12
C19
R938 100
SENS
C11
R937 100
C10
SQSO
0 (AEP, UK)
10k (US, E51, MX)
FLMDCO
S3
SO
SQCK
R939 100
C1
S2
SCK
SCOR
B3
(FOR CHECK)
S1
SI
CN902
23P
VDD
R527 100
U1
R528 100
U2
R529 100
U3
R530 100
U4
R531 100
U5
∗ R945
I2C_CLK
Q901
DTA114EKAT146
I2C_DATA
4.7k
GND
(E51,MX)
R761
10k
10k (US)
R980
4.7k
150k (AEP,UK)
USB_ACK
D902
1SS355
D906
1SS355
R984
100
Q901,906
B+ SWITCH
D904
1SS355
(Page 46)
Q906
DTC144EKAT146
K7
D911
1SS355TE-17
D905
1SS355
R968
1k
A1
TREBLE
K6
VIN
C901
100
10V
BASS
K5
+4V REGULATOR
R969
27k
VOL
K4
R985
1k
Q904
2SB1068TP
CN903
8P
R989 47k
A5
END SW
CAPSTAN/REEL
VOUT
R986
1k
NOISE
CN905
19P
R981
470
CONT
USB_VBUS_ON
GND
USB_INT
MOTOR DRIVER
GND
DECK BLOCK
MOTOR
K3
KEY3
IC905
MM1614A
VOLTAGE DETECT
K2
GENERATOR
B5
IC902
BD4923G
CL
B4
DI
B3
I-RMC
B2
C931
10
50V
VDD
GND
RESET SIGNAL
B6
CE
NC
INH
NC
RESET
K1
KEY1
O
R988
1k
G
C925
0.1
C932
0.1
C933
22
25V
C934
100
16V
C935
0.022
R990 47k
PACK
THE ASSEMBLED
A8
Q905
2SB1116-TP
-LK
A2
I
SUPPLIED WITH
A6
R987
1k
IC904
M62703ML
KEY2
(Page 61)
TAPE MECHANISM
SOL
JOG
PLUNGER
R991 47k
BLOCK
F.REC
A9
R992 47k
R.REC
A7
R763 47k
PLAY SW
DRIVE
D907
1SS355
C936
100
16V
D910
MA8100-M
C914
0.1
(EXCEPT US)
C953
0.022
EVER3.3V
LCK
B1
INH
CLK
O-SHIFT_SO
DATA
B7
STBY
(Page 46)
VDD
GND
VM
44
44
CX-BK1
8-14. SCHEMATIC DIAGRAM – MAIN Board (2/4) –
(2/4)
(AEP,UK)
IC604
GP1FA313TZ
DIGITAL
OPTICAL
OUT
C668
47
16V
C669
0.1
A1
OPTICAL
TRANSCEIVER
A2
CD_D-OUT
D-GND
(Page 44)
A3
A4
C664
10
50V
(E51,MX)
A5
CN504
5P
R699
5.6k
MIC-OUT
R516 22k
R513
22k
10V
R517
100
C517 0.1
C639
100
25V
R643
1.2k
AUX AUDIO SELECTOR
R514
22k
CN004
17P
R645
2.2k
IC501
BU4052
C643
4.7
50V
R526 100
D-GND
R607 0
V-IN
JR607 0
V-GND
INH
X3
A
VSS
B
D-GND
R509
10k
R512
22k
USB-L
C611
4.7
50V
C665
220p
R693
100
A
R510
10k
A-GND
B
X4
R625
10k
R630
10k
(Page 46)
JR615
0
R621
15k
C619
0.047
R523
0
USB-R
A8
C655
270p
C661
220p
A9
Q607
2SD1306NE
VIDEO OUT
R627
4.7k
R601
4.7k
CLOCK
R629 10
DATA
D613 1SS355
GND
SWOUT
SAOUT
OUT1
BB-B1
VCC
OUT2
BB_B2
BB_A2
VOLIN2
BB-A1
VOLIN1
TOUT2
TOUT1
TCC2
TCB2
TCB1
TCC1
TCA2
TMO2
TMO1
TCA1
TMI2
RECB-2
AUX-L
TAPE-L
CD-L
D611
1SS355
A10
R674
100k
C656
0.1
(E51,MX)
MUTING
(US,AEP,UK)
C657
100
16V
C604
4.7
50V
R603
22k
C666
220p
Q602
2SC3052F-T
1-LF
R648
4.7k
LINE AMP
Q604
2SD1306NE
R642
1.2k
B3
B2
MUTING
R605
27k
C618
10
50V
R618
2.2k
R670
100
O-MCLOCK
O-MDATA
LEVEL
C636 0.22
C632 0.22
R620 1k
R628
22k
50V
R694
2.7k
C654 270p
R623 R624
2.2k
2.2k
A11
Q608
2SA1235TP
R662
0
JR614
0
C693
0.47
50V
R696
100k
C603
100
16V
C638
100
25V
C653
470p
(Page 47)
45
45
INVERTER
R663
10k
R664
18k
REC-OUT-MUTE
R665 1M
C610
4.7
50V
C692 4.7
C637
10
25V
R622
15k
R626
10k
R610 0
B7
R644
2.2k
REC-R
R640
2.2M
JR616
0
B6
R650
0
B5
C614
0.001
B4
C694
0
R652
47k
JR611 0
C602
10
50V
(EXCEPT US)
R
C628
0.0027
R614 0
R651 47k
X2
TAPE-R
L
AUX OUT
X1
C615 0.001
R616 0
TUNER-R
R649
0
C662 220p
C626
0.047
B10
R602
4.7k
C624
1
50V
B8
R
JR610 0
R647
4.7k
R604 22k
B9
AUX IN
C634 0.022
JR624
0
L
C622 0.022
JK602
4P
TMI1
IC601
M61529 FP
RECB-1
C502
10
50V
AUX-R
C501
10
50V
JK603
1P
VOLUME
R522
0
TAPE-R
R521
0
REF
C606
0.1
TUNER-L
ELECTRICAL
TUNER-R
INPUT SELECT/
SUR2/DPL2
C504
4.7
50V
CD-R
AUX2-R
MIC
AUX2-L
SUR1/DPL1
R511 22k
A-GND
B1
(Page
49)
VEE
C507
0.1
R698
5.6k
C631 0.22
X0
VM
C617
10
50V
R617
2.2k
C627 0.0027
Y1
R675
2.2k
0.022
COM X
0.047
Y3
C633
USB_ON
C625
R692
100
C508 0.1
USB_ON
0.022
USB_VBUS_ON
1 50V
R524
0
USB_VBUS_ON
C623
USB_INT
USB_INT
C621
X1
USB_ACK
USB_ACK
C691
4.7
50V
LINE AMP
C601
10
50V
(EXCEPT US)
X2
COM Y
I2C_DATA
C663
10
50V
R609
0
R613 0
Y2
C613
4.7
50V
R606
27k
R641
2.2M
R615 0
VDD
A7
Q605
2SC3052F-T
1-LF
I2C_CLK
Y0
R697
100k
JR617
0
I2C_CLK
I2C_DATA
R695
2.7k
R619 1k
C518 100
R518
100
C635 0.22
C503
4.7
50V
10V
X3
LCK
(Page 51)
C519 100
JR613 0
R525
100
JR612 0
LCK
TAPE-L
VM
REC-L
A6
D501 UDZSTE173.9B
TUNER-L
I-MIC
I-MIC
R671
100
R676
2.2k
R515
22k
MIC-A-GND
CX-BK1
• See page 68 for IC Block Diagrams.
I2C_CLK
USB_ACK
I2C_DATA
I2C_CLK
I2C_DATA
USB_INT
USB_INT
USB_ACK
INH
USB_VBUS_ON
(Page 44)
USB_VBUS_ON
Z8
O-SHIFT_SO
O-SHIFT_DATA
O-SHIFT_STB
O-SHIFT_CLK
R765 5.6k
R769 5.6k
Z2
Z3
HEADPHONE
O-POWER-MONITOR
R767 5.6k
O-POWER_MONITOR
I-HEADPHONE
Z5
Z4
O-POWER
O-MCLOCK
O-MDATA
MUTE
VSTBY
LEVEL
Y5
Y2
Y3
Y4
Z1
SOL
MOTOR
POWER
MCLOCK
FR-VDD(3.3V)
MDATA
+12V
FR-GND
MUTE
V-STBY
VM_D
LEVEL
A-GND
DO
STEREO
TUNED
CE
TU-SIG(ECHO_CE)
RDS-DATA
RDS-CLK
Y1
(3/4)
EVER3.3V
(Page 44)
(Page 44)
Z9
8-15. SCHEMATIC DIAGRAM – MAIN Board (3/4) –
(AEP,UK)
I-MIC
CN508
15P
Y1
RDS DATA
LCK
RDS INT
(AEP,UK)
FM SIGNAL OUT
C876
4.7
50V
C872
0.0033
C866
10
50V
C873
0.0033
+3V(RDS)
TU-MUTE
R884
3.9k
R880
5.6k
R885
3.9k
R887
5.6k
C477
4.7
50V
Q891,892
R893
10k
REGULATOR
FM 75Ω
R962
10k
+9V
REGULATOR
CONTROL
C883
4.7
50V
C882
4.7
50V
Q890
KTA1266GR
C894
0.1
R890
47k
R888
100
R879
1k
TUNER-R
FM/AM
SUPPLIED WITH
TUNER-L
R894
0
Y2
C867
0.01
(COAXIAL)
TUNER PACK
GND
THE ASSEMBLED
STEREO
BLOCK
Y3
A1
TUNED
R895
2.2k
Q892
2SC3052F-T
1-LF
Q891
2SC3052F-T
1-LF
VM+9V
AM LOOP
Y4
R863
68
CE
DI
TUNER-L
TUNER-R
R896
2.7k
R892
2.2k
R891
2.2k
R881
47k
C892
47
16V
Y5
DO
CLK
CN509
11P
TU-MUTE
TUNER-R
GND
A2
TUNER-L
STEREO
TUNED
A3
JW011
A4
VM+9V
CE
DI
DO
A5
CLK
A6
(EXCEPT AEP,UK)
CN009
11P
(EXCEPT US)
IC701
BU2099FV
A7
VSS
(Page 45)
C702
0.47
NC
OE
DATA
SO
DECK-D-GND
IC703
BU2099FV
VDD
VSS
+12V
Q0
C700
0.47
O-BIAS
Q1
REC-MUTE
VDD
VM_A
Z8
REC-OUT-MUTE
R770 0
USB_ON
Q0
Q9
SO
Z2
C791
100p
Z1
CLOCK
Q11
LCK
Q10
R783 47k
B
Q10
DATA
REC/PB SW
R782 47k
LCK
C790
100p
Q2
R785 47k
R780 0
Z1
OE
R784 47k
Q11
NC
Z3
R787 47k
CLOCK
C792
100p
Z9
R786 47k
R781 0
Z2
A-GND
REC-R
REC-R
(Page
41)
TAPE-R
PB-R
JR709
0
REC-L
24
REC-L
TAPE-L
Z5
R771 0
Z4
R772 0
A
R773 0
VSTBY
Q1
Q0
Q8
Q2
Q7
Q3
Q6
R778
0
R789
47k
R768
10k
R788
47k
Q0
Q1
Q8
Q2
Q7
Q2
R774 0
V-BASS
Q4
JR702
0
JR708
0
23
JR707
0
22
JR706
0
21
JR705
0
20
PB-L
Q9
Q1
CN502
11P
(AEP,UK)
Q5
Q3
Q6
Q4
Q5
AMP-A-GND
JR704
18
0
IN-L
19
C607 100p
AMP-A-GND
JR703
0
R759
4.7k
R756
4.7k
SHIFT REGISTER
IN-R
C608 100p
R755
4.7k
AMP-A-GND
SHIFT REGISTER
MIXOUT-LR
R779 0
CD_ON
(AEP,UK)
AMP-A-GND
MUTE
MUTE
O-POWER_MONITOR
POWER MONITOR
A8
O-POWER
A9
O-POWER
I-HEADPHONE
A10
SYSTEM-MUTE
C5
C3
C1
C2
A11
(Page 47)
46
46
(Page 52)
CX-BK1
8-16. SCHEMATIC DIAGRAM – MAIN Board (4/4) –
• See page 68 for IC Block Diagram.
B10
B8
B9
B7
B6
B5
B4
B3
B1
B2
(Page 45)
VSTBY
(4/4)
R681
220k
R677
22k
CN007
4P
Q625
2SC3052F-T
1-LF
VSTBY(+9V)
R680
220k
M-GND
R679
100k
FEED BACK
C675
0.015
Q624
2SK2158
SWITCH
TUNER/AUX GND
R678
220k
(Page 63)
C1
BOOST
C676
1
50V
C2
CONTROL
X2
X1
C3
C686
4.7
50V
R655
4.7k
C630
4.7
50V
R657
1k
D612
1SS355
R656
5.6k
(Page 46)
R660
3.3k
C640
47
16V
R672
4.7k
Q614
2SK2158
C684
0.033
Q615
2SK2158
Q616
2SK2158
19
18
C682
0.0033
R658
820
R636
27k
20
R689
4.7k
C5
R659
2.2k
Q614-616
FREQUENCY CONTROL
R683
82k
R682
47k
R684
10k
R685
47k
R687
1.5k
R688
1.5k
21
GND
GOUT
GIN
Q617
2SK2158
LPIN
22
Q618
2SK2158
V+
VREF
BBE
OUTB
OUTA
LPOUT
LINB
LOUTB
LINA
INA
ENHANCER
LOUTA
HINB
HINA
BASS BOOST
HOUTA
HOUTB
INB
R686
8.2k
23
IC603
NJM2156
Q619
2SK2158
C696
C683
0.0033
0.22
R635
56k
24
C685
0.033
Q620
2SK2158
C677
0.1
R669
4.7k
C697
0.22
R667
10k
Q617-620
CN507
11P
R666
270
BOOST CONTROL
ROUT
C645
22
16V
C629
4.7
50V
X4
Q024
2SB1013
R668
4.7k
Q623
2SC3052F-T
1-LF
V-BASS
BBE ON/OFF
X3
C687
4.7
50V
C641
47
16V
A-GND
LOUT
R032
47k
CONTROL
RF-GND
R020
0
A-VDD(3.3V)
D-GND
Q024,025
R031
470
B+ SWITCH
D-GND
D-VDD(3.3V)
C015
100
16V
(Page 37)
MGND
C016
1000
16V
MGND
CD-VM(7V)
CD_ON
R003
0
Q25
DTC114YKA
C019
47
25V
C20
0.1
IC101
TA7810S
1A
VM+9.0V
VCC
I
Q019
2SB1370E
Q050,051
+9V REGULATOR
R016
470
Q051
2SA1015
GR
O
G
GND(+12V)
R050
100k
+12V
D050
1SS355
R011
2.2
R017
47k
R038
220
R018
100
Q050
2SC3052F-T
1-LF
GND(+7.0V)
Q018
2SC3052F
D016
1SS355
D017
1SS355
+7.0V
(Page 53)
C007
22
50V
C011
0.1
C012
0.1
C013
47
25V
C050
10
50V
M-GND
D018
1SS355
O-POWER
+10V REGULATOR
CN006
6P
C018
100
10V
R052
8.2k
R053
18k
C052
47
25V
C014
470
16V
47
47
D015
MA8033-L
TW
C017
10
50V
Q018,019
+3.3V REGULATOR
R019
470
(Page 44)
CX-BK1
8-17. PRINTED WIRING BOARD – USB AUX Board –
• See page 35 for Circuit Boards Location.
:Uses unleaded solder.
USB AUX BOARD
EP702
C725
JW704
EP702
C724
R736
R712
C759
C713
C716
C709
IC700
JR701
C758
C720
C711
R731
R732
C714
JW700
C706
1
C756
C755
R707
44
11
C705
34
R
C702
R703
C703
JW703
C704
R702
R704
X700
C715
R729
C760
R705
JW702
(CHASSIS)
R706
R735
AUDIO
R711
J701
LINE IN
L
L703
JW725
R730
12
R720
R718
C718
C722
3
33
C710
JW724
22
R716
JW723
C721
JW721
JW720
C717
1
IC701
23
C708
R710
JW722
R721
C712
JW718
R726
VIDEO
C762
JW719
JR703
C700
C701
R725
C719
Q701
R724
R701
R700
Q702
JW717
E
JW716
E
R723
JR702
JW715
Q700
EP701
JW714
CN701
R727
JW713
JW711
JW712
JW709
JW710
E
JW707
JW706
JW708
JW705
R722
R728
C757
L701
L702
L705
L700
2 3
(USB)
1 4
13
CLP701
1-688-415-
G
48
48
MAIN BOARD
CN004
(Page 43)
(CHASSIS)
(FRONT VIEW)
(13)
CX-BK1
8-18. SCHEMATIC DIAGRAM – USB AUX Board –
• See page 42 for Waveform.
R700 22
C710
0.1
R701 22
C700
22p
C719
0.1
C717
33
25V
Q702
DTA114EKA-T146
C701
22p
USB ON/OFF SWITCH
+5V REGULATOR
C708
0.47
IC701
NJM78M05S
C712
0.47
O
R710
220k
Q701
2SB1132-T1
01-R
I
G
R723
1k
Q700,701
B+ SWITCH
R720 3.3k
R718 3.3k
R721 3.3k
R716 3.3k
R722
4.7k
C721
0.1
Q700
DTC114EKA
-T146
C722
0.1
C703
1000p
L702
0
R703
15k
FOUTL
R727 100
VBUS
D-
VREG
D+
VSS
VDD
TEST
SEN
C705
220p
REST
L705
0
SOF
R705 8.2k
(USB)
SUSPEND
CN701
17P
R706 15k
J700
I2C_CLK
R726 100
I2C_DATA
R725 100
TRDY
USB_ACK
R724 100
FOPL
SCL
FINL
SDA
USB_INT
R728 100
L701
0
FOUTR
NC
USB_ON
FOPR
NC
VM
FINR
NC
D-GND
NC
V-IN
NC
V-GND
NC
D-GND
R704 8.2k
R702
15k
L700
0
C704
220p
USB INTERFACE
NC
IC700
µAC3553B
NC
SGND
C724
100p
A-GND
INT_DATA
USB-L
USB-R
CLI
WSI
R729 680
DAI
AVDD
AREG0
OUTR
R730 680
OUTL
XTI
C757
0.22
A-GND
C756
4.7
50V
AUX2-L
L703
0
C718
0.1
C725
100p
C760
0.47
(CHASSIS)
XTO
NC
AVSS_12
C755
100p
ACK
AREG1
SREF
EP701
USB_VBUS_ON
R707 15k
C702
1000p
EP702
(CHASSIS)
R732
100k
C762
0.22
R731
33
C716
10
50V
JR701
0
X700
12MHz
C711
22p
C714
22p
C715
100
10V
C713
10
50V
C706
0.01
C759
47
10V
JW704
0.45µH
C758
100
10V
JW702
0.45µH
VIDEO
JR703
0
J701
3P
JR702
0
L
LINE IN
AUDIO
R
R711
4.7k
R735
22k
R712
4.7k
R736
22k
49
49
C709
0.1
C720
0.1
AUX2-R
(Page 45)
CX-BK1
8-19. PRINTED WIRING BOARD – MIC Board (Chilean, Peruvian and Mexican models) –
• See page 35 for Circuit Boards Location.
:Uses unleaded solder.
MIC BOARD
VR201
MIC MIXING
F
(Page 43)
MAIN BOARD
CN504
C216
CN205
R211
IC201
R214
R201
C209
JW210
R210
C211
R213
JR204
J201
MIC
R232
R212
JW209
C212
C206
C213
C210
C204
C219
Q201
R203
R216
E
C203
FB201
R209
C205
JW201
R205
R202
R215
JW208
R206 C207
D202
D201 C208
R204
R207
13
R208
1-688-406-
W201
(CHASSIS)
50
50
(13)
CX-BK1
8-20. SCHEMATIC DIAGRAM – MIC Board (Chilean, Peruvian and Mexican models) –
CN205
5P
R208
100
LCK(NC)
VM
I-MIC
MIC-OUT
C212
0.47
50V
C211
820p
R213
33k
R214
10
MIC-A-GND
C209
10
50V
(Page 45)
R210
2.2k
8
R204
100
3
1
2
C204
0.22
50V
R202
4.7k
J201
C208
1
50V
C216
0.47
50V
IC201(2/2)
NJM4565M-TE2
5
R205
2.2k
IC201(1/2)
NJM4565M-TE2
MIC
7
VR201
10K
6
R232
10k
4
C213
2.2
50V
R215
470
R212
2.2k
MIC AMP
MIC
MIXING
C207
120p
R206
270k
W201
D202
1SS355
TE-17
D201
1SS355
TE-17
R209
470
R216
1k
R207
1k
S
R211
2.2k
C206
220
10V
C205
10
50V
Q201
2SK2158
R203
220k
MIC LEVEL
AGC
R201
10k
(CHASSIS)
FB201
C203
4700p
C210
22
50V
C219
0.22
51
51
CX-BK1
8-21. SCHEMATIC DIAGRAM – AMP Board (1/2) –
(1/2)
EP502
R541
2.2k
R543
2.2k
(E51,MX)
1k 1/4W
(US,AEP,UK)
R539
10k
470 (US)
C519
820p
R553
27k
R549
Q525
2SD1306
NE 07-TL
CN502
11P
∗
C513
22
50V
MUTING
AMP-A-GND
C507
100p
100V
C509
820p
AMP-A-GND
MIXOUT-LR
MUTING
AMP-A-GND
CONTROL
R564
0
C520
820p
R558
1k
R550
Q526
2SD1306
NE 07-TL
POWER MONITOR
O-POWER
R592
15k
SYSTEM-MUTE
(US,E51,MX)
(AEP,UK)
R513
6.8k
R035
22k
R036
22k
D509
1SS184
-TE85L
CN504
5P
C501
0.01
R507
GND
∗
O-P0WER
(EXCEPT US)
R501
0.22
3W
Q509
2SC3052F-T
1-LF
R515
220
Q515
2SC2713G-T
E85L
R527
47k
R503
0.22
3W
R595
R509
2.7k
∗
Q505
2SA1163G-T
E85L
R-IN
OVER LOAD
RELAY SW
L-IN
DETECT
R511
1k
R597
D511
1SS355TE
-17
R574
22
R514
6.8k
∗
R535
100
Q511
2SC2910ST
-P
CASCADE
(Page 55)
R575
10k
Q533
Q511,513,515
R576
10k
RY501
Q513
2SC2910ST
-P
Q521
2SC3052F-T
1-LF
Q523
2SC3052F-T
1-LF
∗
MUTE
2SD1588
(US)
2SD1649
(E51,MX)
Q530
2SC3052F-T
1-LF
FP1016
(AEP,UK)
RELAY
DRIVE
Q531,533
FINAL DRIVE
C575
0.1
Q521,523
CURRENT
R533
100
R525
1k
MIRROR
R519
39
R517
39
MUTING
R562
1M
∗ R595-598
R542
2.2k
R540
10k
D504
1SS184-TE85L
R530
4.7k
R544
2.2k
R560
3.9k
0.22 2W
(AEP,UK)
0.47 2W
(E51,MX)
Q532
R538
R591
100k
1k 1/2W
(E51,MX)
1k 1/4W
(US,AEP,UK)
Q508,510
D502
1SS181-TE85L
2SD2439
(US)
2SD2562
(E51,MX)
FN1016
(AEP,UK)
∗ R508
BIAS
R506
100
C522
4.7
50V
R546
100
(US,E51,MX)
1.5k
(AEP,UK)
-2
Q518
HN4A06J-GRBL
TE85R
Q508
2SC3052F-T
1-LF
R524
2.2k
PRE DRIVE
R548 27k
C512 33 35V
1.2k
R522
1.8k
-1
C518
0.47
50V
R508
C536
0.1
50V
R502
0.22
3W
Q510
2SC3052F-T
1-LF
C506
100p
100V
C502
0.01
∗
Q506
2SA1163G-T
E85L
(EXCEPT US)
C508
100p
100V
C510
820p
R596
∗
R510
2.7k
OVER LOAD
DETECT
R512
1k
R532
1.5k
R516
220
D506
AU-01Z
R504
0.22
3W
R598
∗
(US,E51,MX)
D508
1SS355TE
-17
R528
47k
Q514
2SC2910ST
-P
Q516
2SC2713G-T
E85L
Q522
2SC3052F-T
1-LF
Q524
2SC3052F-T
1-LF
R536
100
Q534
Q512
2SC2910ST
-P
Q512,514,516
2SD1588
(US)
2SD1649
(E51,MX)
FP1016
(AEP,UK)
Q532,534
FINAL DRIVE
CASCADE
Q522,524
CURRENT
R534
100
MIRROR
R526
1k
R520
39
R518
39
R067
47k
Q013
2SA1163G-T
E85L
C026
4700p
D020
1SS184-TE85L
OVER CURRENT
DETECT
A15
A14
A13
A11
A12
HOLD
A8
R068
10k
A9
C025
6800p
A7
A6
A5
A3
A1
Q012
2SC2713G-T
E85L
R066
33k
R090
10k
A10
R065
10k
A2
(Page 46)
C505
100p
100V
C514
22
50V
R554
27k
Q507
2SC3052F-T
1-LF
R531
1.5k
D507
1SS355TE
-17
R556
100k
∗ R507
1.2k
R505
100 1.5k
(US,E51,MX)
AMP-A-GND
R561
Q527 68k
2SA1235
(AEP,UK)
C537
0.1
50V
D505
AU-01Z
IN-L
IN-R
(E51,MX)
FN1016
PRE DRIVE
C511 33 35V
R555
100k
C528
0.1
R523
2.2k
560 (AEP,UK)
R547 27k
C523
0.1
(US)
2SD2562
-2
Q517
HN4A06J-GRBL
TE85R
390 (E51,MX)
R557
1k
2SD2439
R521
1.8k
-1
(CHASSIS)
BIAS
R545
100
∗ R549,550
EP501
Q507,509
D501
1SS181-TE85L
-2
C517
0.47
50V
Q531
-1
C521
4.7
50V
(CHASSIS)
C524
0.1
1k 1/2W
D510
1SS181-TE85L
R559
3.9k
D503
1SS184-TE85L
R529
4.7k
R537
R037
5.6k
(Page 53)
The components identified by mark 0 or dotted
line with mark 0 are critical for safety.
Replace only with part number specified.
52
52
CX-BK1
8-22. SCHEMATIC DIAGRAM – AMP Board (2/2) –
A15
A14
A13
A11
A12
A10
A8
A9
A7
A5
A6
A3
A1
A2
(Page 52)
(2/2)
R681
15k
1/2W
R686
3.3k
Q618
2SK3053
C636
100p
R695
22k
D629
1SS355TE-17
C637
47
63V
D623
1SS355TE-17
SWITCHING
R699
3.3k
Q620,621
D626
FMB-G16L
∗ R697,698
OUTPUT LEVEL
R676
2.7k
DETECT
Q620
2SD814A(RS)
D624
1SS355TE-17
R692
3.3k
VH-
JW012
SP-GND
SP-GND
VM+9V
(Page 63)
(EXCEPT US)
FAMP-A-GND
R675
2.2k
C640
330p
R643
R653
3.3k
∗
D633
1SS355TE
-17
R669
10k
R641
22k
R664
3.3k
D637
1SS355TE
-17
TH502
D634
1SS355TE
-17
R660
2.7k
C642
22p
Q623
2SA1235
R671
10k
D635
1SS355TE
-17
Q617,622-624
R656
1.8k
OUTPUT LEVEL
C634
47
63V
DETECT
R655
1.5k
R649
220k
C643
330p
Q624
2SA1235
D636
1SS355TE
-17
R654
15k
D638
1SS355TE
-17
CN601
4P
FR SP OUT(R)
FR SP GND(R)
FR SP OUT(L)
R648
220k
FR SP GND(L)
Q611
DTA114EKA
-T146
C645
330p
R677
3.3k
R670
15k
TH501
R651
2.2k
R311
4.7k
Q610
2SA1163G-T
E85L
R652
47k
R626
3.3k
JW602
POWER-MONITOR
∗
C630
330p
Q617
2SA1235
D627
FMB-G16L
R697
∗
R646 47k
R659
270
R685
2.2k
R672
4.7k
VL-
R698
R647 22k
R679
5.6k
SWITCHING
VL+
R663
10k
R645 47k
Q622
2SB792A(RS)
R691
120
VH+
Q619
2SK3053
C631
330p
R650
10k
∗ R642,643
O-POWER
D618
1SS184-TE85L
CN004
13P
R678
33k
R696
15k
R661
3.3k
D619
1SS181-TE85L
D630
UDZSTE1715B
R674
47k
R658
330
(US,AEP,UK)
R662 10k
C635
0.068
C641
47
35V
Q621
2SC3052F-T
1-LF
(E51,MX)
1.8k
D632
1SS355TE-17
R694
10k
C638
330p
D625
MA8180
C633
47
35V
1.5k
R642 ∗
JW601
R682
15k
R693
3.3k
R627 10k
R683
4.7k
D631
1SS355TE-17
(Page 57)
R312
4.7k
D301
1SS184
Q610,611
THERMAL DETECT
1.8k
(E51,MX)
2.2k
(US,AEP,UK)
RELAY GND
DC-DET
CN006
6P
JW016
D002
1SS355
+7.0V
JW023
C301
1
50V
GND(+7.0V)
+12V
GND(+12V)
JW014
+12V REGULATOR
VCC
IC003
TA7812S
VM+9.0V
+7V REGULATOR
(Page 47)
I
R301
47k
G
IC001
TA7807S
I
R302
470k
O
C302
47
25V
O
G
JW017
Q301
2SC3052F
R305
10k
R303
3.3k
R304
220
R306
10k
CN003
4P
REG
Q301-303
Q302
2SA1235F
FAN MOTOR DRIVE
C303
47
25V
(US)
JW013
C004
22
50V
C001
0.1
C002
0.1
C003
47
25V
C005
22
50V
C007
0.1
C008
0.1
CN303
3P
REG-GND(+7V)
REG-GND(+4V)
C009
47
25V
JW041 JW042
M301
(FAN)
REG-GND(+12V)
R307
3.9
(Page 63)
53
53
Q303
2SA1015GR
CX-BK1
8-23. PRINTED WIRING BOARD – AMP Board –
1
2
A
3
• See page 35 for Circuit Boards Location.
4
5
6
7
:Uses unleaded solder.
8
9
10
11
12
14
15
16
17
18
Q527
R575
4
CN601
1
R503
JW518
JW514
(EXCEPT US)
5
R502
C645
D
Q619
S
G
JR1130
JR1117
JR1116
JR1115
JR1114
JR1113
JW017
(US)
JW611
R670
4
E
R654
CN003
JW027
R694
MAIN
BOARD
CN502
1
Q624
R677
E
JR515
JW041
C643
R655
JW042
JW013
(Page 43)
R693
I
Q620
C635
JW616
Q617 R672
E
R674
C634
D636
D625
E
C638
R692
R682
I
C633
CN004
D629
R695
1
JW545
MAIN
BOARD
CN006
(Page 43)
E
R691
6
CN006
1
R685
C636
C637
JW602
Q621
R676
R681
JW615
13
JW524
JW023
Q514
R675
E
R656
D624
JW613
(Page 55)
R696
D632
Q623
D634
JW614
(Page 56)
(CHASSIS)
CN502
JW029
D631
R678
C641
HEADPHONE
BOARD
CN530
JW516
SPEAKER
BOARD
CN503
D638 C642
D635
R679
JW517
K
R641
R671
JW617
R658
L
C007
JW030
R598
JR514
E
D
S
Q618
R683
H
R504
R698
Q622
JW612
G
C004
C523
R659
JW618
JW541
EP501
JW031
R661
D637
D626
D633
JW515
C003
R664
JW544
JW540
1
C009
R697
R648
1
3
1
JW522
R647
CN504
JW523
JW528
JW529
E
R642
(US, E51, MX)
JR517
R597
Q510
E
D627
E
G
R501
Q508
R627
R596
R595
-2
IC003
JW036
C575
Q530
JW512
3
JW038
D623
D002
R305
JW025
D630
JW016
JW035
R312
A
R649
JW619
A
JW511
JW513
(EXCEPT US)
R311
D301
D511
(US, E51, MX)
K
(EXCEPT US)
-1
RY501
IC001
Q534
C008
C001
JW028
JW520
JW519
R574
C002
R516
R699
R509
R576
K
JW543
R524
JW521
E
JW034
3
Q303
2
JW022
Q301
Q302
E
E
JW012
(EXCEPT US)
C302
R307
C303
1
E
R304
R301
JW021
JW601
R302
JW020
R306
CN303
J
R303
C301
11
1-688-420-
K
M
Ref. No.
Location
D002
D020
D301
D501
D502
D503
D504
I-14
B-3
F-3
D-6
D-11
C-6
D-11
Ref. No.
D505
D506
D507
D508
D509
D510
D511
N
ACDC BOARD
CN003
(Page 62)
• Semiconductor Location
Location
D-5
D-9
C-5
C-9
D-3
C-11
F-2
Ref. No.
D618
D619
D623
D624
D625
D626
D627
Location
E-7
E-8
I-11
H-8
H-9
G-9
G-7
Ref. No.
D629
D630
D631
D632
D633
D634
D635
Location
I-11
J-11
G-11
G-11
G-9
H-9
H-9
C528
Q532
R510
JW542
E
R522
K K
R646
Q509
Q507
K
JW014
A
R645
R523
R507
TH502
(EXCEPT US)
A
JW539
R508
D619
C005
D502
A
D618
Q533
JR512
R686
JW024
R521
Q531
E
R505
C501
(CHASSIS)
K
C536
(US, E51, MX)
EP502
K
JW033
A
A
R520
R518
R506
E
R515
Q505
E
K
JR511
C506
R663
C505
C507
A
JW032
R538
D504
E
C631
TH501
D501
E
C508
Q506
R037
R036
(UK)
K
JR513
C502
R662
Q611
E
R514
A
R519
E
D506
(MX)
K
C512
R526
Q512
Q513
R517
Q516
C510
R512
E
R530
R528
R532
Q511
E
R651
R652
E
C537
C630
A
R537
C511
R525
K
R542 R544
R548
R660
A
R513
E
D505
E
R511
R536
R529
Q515
Q524
(E51)
R035
A
C520 R546
D508
Q518
1B
2B
E
R540
1C 2C
E
R547
R527
C509
Q610
D509
C524
1C 2C
E
R531
R534
R541 R543
A
C640
E
D
JW530
A
R535
R650
D503
R551
2B
R669
Q523
(US)
D510
R653
C519 R545
D507 Q517
1B
E
JW538
R550
Q522
K
R533
C026
K
JW534
Q521
JW526
R556
E
R549
R068
R067
C518 R554
R643
E
R558
R555
E
(AEP)
JW527
Q526
R626
C025
R553
R591
E
R562
C514
(US, E51, MX)
Q013
C
C517
R557
Q525
JW531
E
JW532
A A
R065
C513
JW533
Q012
R539
D020
JW537
R090
K
JW536
R066
JW535
R561
B
JW037
R560
R592
C522
JW525
R559
R564
AMP BOARD
C521
F
13
ACDC BOARD
CN006
(Page 62)
Ref. No.
D636
D637
D638
Location
H-10
G-10
G-10
IC001
IC003
E-13
E-17
Ref. No.
Q012
Q013
Q301
Q302
Q303
Q505
Q506
54
Location
B-3
C-2
J-14
J-14
J-15
E-3
D-8
Ref. No.
Q507
Q508
Q509
Q510
Q511
Q512
Q513
54
Location
E-5
E-9
E-5
E-9
D-5
D-10
D-6
Ref. No.
Q514
Q515
Q516
Q517
Q518
Q521
Q522
Location
D-10
D-5
D-9
C-5
C-10
C-4
C-9
Ref. No.
Q523
Q524
Q525
Q526
Q527
Q530
Q531
Location
C-4
C-9
C-4
C-8
B-11
G-2
E-4
Ref. No.
Q532
Q533
Q534
Q610
Q611
Q617
Q618
Location
E-9
E-6
E-11
D-4
E-4
H-6
H-8
Ref. No.
Q619
Q620
Q621
Q622
Q623
Q624
Location
H-6
H-11
I-12
G-9
G-10
H-11
(11)
M
M301
(FAN)
CX-BK1
8-24. PRINTED WIRING BOARD – HEADPHONE Board –
• See page 35 for Circuit Boards Location.
8-25. SCHEMATIC DIAGRAM – HEADPHONE Board –
:Uses unleaded solder.
HEADPHONE BOARD
JW524
1
AMP
BOARD
CN504
R523
JR501
5
R521
W505
(Page 54)
C550
R526
CN530
5P
J521
PHONES
JW523
GND
C521
K
CN530
R525
JW523
O-P0WER
J521
R-IN
PHONES
L-IN
R524
R522 1-688-414-
11
RELAY SW
(11)
(Page 52)
W505
R522
2.2k
(CHASSIS)
55
55
R526
270
1/2W
R524
270
1/2W
R525
270
1/2W
R523
270
1/2W
R521
2.2k
C550
0.22
(CHASSIS)
CX-BK1
8-26. PRINTED WIRING BOARD – SPEAKER Board –
• See page 35 for Circuit Boards Location.
:Uses unleaded solder.
SPEAKER BOARD
R573
R571
+
C525
JW506
L501
C533
L
CN503
L
–
C527
+
C535
R
R570
–
R572
AMP
BOARD
CN601
(Page 54)
L502
C524
C526
C532
C534
EP502
1-688-419-
56
56
JK502
SPEAKER
(CHASSIS)
11
(11)
CX-BK1
8-27. SCHEMATIC DIAGRAM – SPEAKER Board –
CN503
4P
FR SP OUT(R)
FR SP GND(R)
FR SP OUT(L)
FR SP GND(L)
(Page 53)
L501
1.7µH
R571
10
1/2W
R570
10
1/2W
L502
1.7µH
JK502
4P
C533
0.0022
L
SPEAKER
C532
0.0022
R573
10
R572
10
C525
0.1
C524
0.1
C527
0.1
C526
0.1
C535
0.1
C534
0.1
R
EP502
(CHASSIS)
57
57
CX-BK1
8-28. PRINTED WIRING BOARDS – KEY Section –
• Semiconductor
Location
3
:Uses unleaded solder.
4
5
6
7
Location
LED202
STANDBY/ON
R601
PRESET
C602
S318
S317
STOP/CLEAR
PAUSE/SET
(Except US)
B
B3
1
IC601C609
20
CN605
JR603
JW608
R318
R319
10
PLAY MODE
JW604
REC
(US)
(Except US)
S332
S331
R333
ALBUM/PLAY LIST
R331
C605
R604
LED634
DISC
INDICATOR
4
S314
S315
DISC SELECT
4
DISC SELECT
5
LED635
DISC
INDICATOR
5
E
JR607
S315
CN613
1
2
1-688-412-
CN606
JW626
C608
1
20
10
LED631
DISC
INDICATOR
1
11
LED633
DISC
INDICATOR
3
1C
Q601
2C
1B
E
2B
R617
JR604
S312
1
S337
BAND
JW614
S316
R622
S311
EJECT
5
R330
R338
R310
DISC SELECT 1
DISC SELECT 2
R317
R311
S314
LED635
DISC SELECT 3
S313
R316
R624 R619
13
LED601
DISC SLOT
ILLUMINATION
R337
R608
JW615
IC602
LED634
5
C607
JW623
JR606
LED632
R618
DISC
R314
Q605
INDICATOR
R626
JR611
1B
1C
2
E
2C
2B
R623
JW628
JR605
R621
1B
1C
R312
E
2C
2B
Q603
JR610
R313
LED BOARD
LED601
R620
JR608
JW629
JW611
D
JW622
JW612
C604
R625
4
JW613
Q604 1B
1C
E
2C
2B
IC603
R607
JW621
R335
S336
FUNCTION
3
JW620
R332
R606
C606
1
2
JW619
R334
R336
(Page 60)
JW610
C
LCD VOL
BOARD
CN004
JW602
S319
JW618
P
JR601
JW601
JW617
JW603
DOWN
TUNING
JW605
UP
11
R603
JW616
S334
S333
S335
POWER
C621
C603
R320
JW606
PRESET
C601
R611
S320
(US)
R345
R602
JR602
JW624
D-4
E-4
E-3
D-2
E-3
A
JW609
A-7
E-7
F-1
D-3
E-3
E-3
D-2
E-2
LEFT BUTTON BOARD
S311 − 320,
S331 − 339
S338
GEQ
Q602
1B
1C
E
2C
2B
LED203
R339
JR609
R346
LED203, S339
i-Bass
JW627
LED202
LED203
LED601
LED631
LED632
LED633
LED634
LED635
KEY LED RMC BOARD
JW625
B-4
D-3
C-5
R605
IC601
IC602
IC603
Q601
Q602
Q603
Q604
Q605
2
R315
Ref. No.
1
• See page 35 for Circuit Boards Location.
S339
R616
(13)
CN612
1
2
13
1-688-411-
F
(13)
1
CN607
5
13
1-688-407-
58
58
(13)
CX-BK1
8-29. SCHEMATIC DIAGRAM – KEY Section –
• See page 42 for Waveform.
Q601-605
~~
U4
~
~~
~
G5
~~
G4
~
~~
U3
~
~~
G3
~
~
U2
~~
~~
G2
~
~~
U1
~
~~
G1
~
LED DRIVE
LED601
SLR-325VC
(DISC SLOT ILLUMINATION)
~~
U5
~
CN613
2P
CN612
2P
-1
-2
-1
Q601
FMA9AT148
-2
-1
Q602
FMA9AT148
-2
-1
Q603
FMA9TA148
-2
-1
Q604
FMA9TA148
-2
Q605
FMA9TA148
R616
1k
R617
560
R622
560
R611
100
R618
560
R623
560
R619
560
R624
560
R620
560
R625
560
R621
560
LED631
SML78420C
LED632
SML78420C
LED633
SML78420C
LED634
SML78420C
(DISC INDICATOR 1)
(DISC INDICATOR 2)
(DISC INDICATOR 3)
(DISC INDICATOR 4)
C608
0.47
C621
0.1
R626
560
LED635
SML78420C
NC
G3
G2
U2
G1
U1
VOL_LED1
BACK_LED2
BACK_LED1
CN605
21P
VOL_LED2
(DISC INDICATOR 5)
C609
0.47
STBY
BASS-LED2
BASS-LED2
BASS-LED1
BASS-LED1
TRE-LED2
REMOTE CONTROL
TREBLE-LED2
TRE-LED1
R608
47
Q5
Q6
Q7
Q8
Q9
Q10
Q11
OE
SO
Q5
VDD
Q7
Q6
Q8
Q9
Q4
Q3
Q2
Q1
Q0
LCK
CLK
NC
DATA
Q4
VSS
Q2
Q1
Q3
LCK
VSS
BACKLIGHIT1
KEY2
DATA
IC601
BU2092F
BACK_LED1
NC
LED DRIVE
LED DRIVE
BACK_LED2
BACKLIGHIT2
Q0
VOL-LED1
P
OE
R607
56k
VOL_LED1
CLK
VOL-LED2
VDD
IC603
RPM7238
VOL_LED2
NC
RECEIVER
TREBLE-LED1
IC602
BU2099FV
C607
47
16V
KEY1
I-RMC
A4
C601
100p
LCK
A3
CLK
A2
R601
10k
DATA
C605
100p
R606 10k
C606
100p
C604
100p
R605 10k
GND
C603 100p
GND
R603 10k
VM
C602 100p
R602 10k
VDD
R310
15k
R311
390
R312
680
S311
S312
1
2
R313
1k
R314
1.5k
R315
1.5k
S313
S314
S315
S316
3
4
5
EJECT
R317
3.3k
S317
PAUSE/SET
R318
4.7k
S318
STOP/CLEAR
R319
6.8k
S319
PLAY MODE
~~
U3
~
~~
G4
~
~~
U4
~
~~
G5
~
~~
U5
~
A4
A3
R604 10k
A2
BASS-LED1
TRE-LED1
R316
2.2k
BASS-LED2
A4
TRE-LED2
GND
A3
(Page 61)
R320
10k
S320
LED202
SLI-325URC
PRESET
LED203
SLR325VC
DISC SELECT
(US)
REC
R345
560
STANDBY/ON
R346
1k
PRESET
(Except US)
R330
15k
R331
390
R332
680
R333
1k
R334
1.5k
CN606
5P
CN607
5P
R335
1.5k
S335
S331
S332
S333
S336
R337
3.3k
S337
R338
4.7k
S338
R339
6.8k
S339
S334
UP
LED203,S339
POWER
DOWN
FUNCTION
ALBUM/
PLAY LIST
R336
2.2k
TUNING
59
59
BAND
GEQ
i-Bass
CX-BK1
8-30. PRINTED WIRING BOARDS – LCD Section –
Location
S344
ENTER
7
8
9
LCD VOL BOARD
2
1
A
6
R252
JR108
JR110
JR109
JR111
R251
CN009
CN003
LED251 − 254
(LCD BACKLIGHT)
2
1
LED251
LED253
LED252
LED254
R341
73
1
JW112
S341
TITLE
R105
R110
C105
R101
B
R340
JW111
C104
C110
JW110
C103
R342
C102
CN008
1
2
2
13
1
(13)
1-688-409-
JW113
S342
DISPLAY
JW114
CN002
1
C107
C109
C108
JW115
80
JW116
JW109
R344
C
R343
JW108
65
MODE
JW107
64
24
S343
25
13
1-688-408-
JW117
R107
JW106
JW118
CN010
40
JW141
JW120
41
JW142
R109
JW105
JW119
3
(13)
JW143
R106
R108
IC001
S341 − 344
JW140
1
JW139
JW138
H
JOG BOARD
3
JW121
LCD001
LIQUID CRYSTAL DISPLAY
JW122
JW137
D
JW123
JR105
MAIN
BOARD
CN905
JR104
(Page 43)
JW102
36
37
CN001
JW101
JW131
1
JR106
JW103
CN011
JR101
CN004
R380
R256
JW129
C372
JW125
3
R377
R371
C367
JR102
C371 1
R378
R253
JW134
KEY LED RMC
BOARD
CN605
LED210
3
R375
LED212
LED206
JW135
(Page 58)
LED213
S303
LED207
LED209
(13)
1
LED204 − 221
(ILLUMINATION)
3
R363
LED205
G
LED214
JR103
LED211
TREBLE/
MIDDLE
C363
R365
R361 C361
R258
LED204
JW136
R366
C364
LED221
R257
S301
ROTARY ENCODER
VOLUME
LED216
1
R367
R368
C365
LED208
H
S303
ROTARY ENCODER
LED219
3
C366
R370
LED218
R369
13
1-688-413-
C369
R374
F
1
R373
C368
P
MULTI JOG
R255
LED215
R254
S304
ROTARY ENCODER
R372
R379
R376
JW126
JW130
JW127
C370
JW128
E
JW104
G-7
G-6
F-7
F-7
G-7
F-6
F-8
F-9
F-9
F-8
F-9
E-9
G-8
H-9
G-9
H-8
H-9
G-9
A-6
A-6
A-7
A-7
RIGHT BUTTON (1) BOARD
5
JW124
LED204
LED205
LED206
LED207
LED208
LED209
LED210
LED211
LED212
LED213
LED214
LED215
LED216
LED217
LED218
LED219
LED220
LED221
LED251
LED252
LED253
LED254
RIGHT BUTTON (2) BOARD
4
R364
C-7
3
C362
IC001
2
R362
Ref. No.
1
:Uses unleaded solder.
A4
• Semiconductor
Location
• See page 35 for Circuit Boards Location.
LED220
S302
S302
ROTARY ENCODER
LED217
BASS
1-688-410-
60
60
13
(13)
CX-BK1
8-31. SCHEMATIC DIAGRAM – LCD Section –
L42
L43
L41
L40
L39
L38
L37
L36
L34
L35
L33
L32
L31
L30
L29
L28
L26
L27
L25
L24
L23
L21
L22
L20
L19
C3
C4
C2
C1
L18
L17
L16
L15
L13
L14
L12
L11
L9
L10
L8
L7
L5
L6
L4
L3
L1
L2
R252
180
LCD001
R251
180
R253
270
R254
270
R255
270
R256
270
R257
270
R258
270
LED254
LED,SELU1910CXM
LF38
LED252
LED,SELU1910CXM
LF38
LED206
SLR-325DCT31
P
LED209
SLR-325DCT31
P
LED212
SLR-325DCT31
P
LED215
SLR-325DCT31
P
LED218
SLR-325DCT31
P
LED221
SLR-325DCT31
P
LED253
LED,SELU1910CXM
LF38
LED251
LED,SELU1910CXM
LF38
LED205
SLR-325DCT31
P
LED208
SLR-325DCT31
P
LED211
SLR-325DCT31
P
LED214
SLR-325DCT31
P
LED217
SLR-325DCT31
P
LED220
SLR-325DCT31
P
LED204
SLR-325DCT31
P
LED207
SLR-325DCT31
P
LED210
SLR-325DCT31
P
LED213
SLR-325DCT31
P
LED216
SLR-325DCT31
P
LED219
SLR-325DCT31
P
LIQUID CRYSTAL DISPLAY
LED251-254
L19
L18
L17
L16
L15
L14
L13
L12
L44
L45
L46
L48
L47
C1
C2
C3
L49
C4
L50
L51
L52
L53
L54
L55
L56
L57
L58
L59
L60
L61
L62
L63
L65
L64
(LCD BACKLIGHT)
LED204-221
BAS
VOL
L25
L24
L23
L22
L21
L20
L19
L17
L18
L16
L15
L14
L13
L12
L11
L10
L9
L8
L7
L5
L4
L3
L2
L6
(ILLUMINATION)
R362
68k
R363
15k
S301
R367
68k
ROTARY ENCODER
R368
15k
S302
ROTARY ENCODER
VOLUME
L1
L26
S65
S40
S66
S39
L27
C1
S38
COM2
S37
COM3
S36
COM4
S35
VDD
S34
L29
C3
C104
0.1
L30
C4
C364
1000p
R365
10k
L31
R369
180k
C366
100p
R370
10k
S303
ROTARY ENCODER
L32
R101
47k
R372
68k
L33
VLCD
C105
680p
VLCD1
LCD DRIVER
S32
VLCD2
IC001
LC75874E
S31
TRIBLE/
MIDDLE
L35
R371
10k
C368
100p
L36
VSS
S30
OSC
S29
INH
S28
CE
S27
CL
S26
L37
R110
5.6k
R373
15k
S33
L34
R105
15k
C363
100p
STBY
COM1
C2
C102
100
25V
R364
180k
L28
TRE
C103
0.1
C365
100p
C367
1000p
C110
0.1
R366
10k
C362
100p
C361
1000p
S41
S42
S43
S44
S45
S46
S47
S48
S49
S50
S51
S52
S53
S54
S55
S56
S57
S58
S59
S60
S62
S63
S64
S61
R361
10k
BASS
L38
L39
L40
R374
180k
C369
100p
R375
10k
CN004
21P
L41
CN001
19P
VOL
VOL
JOG
JOG
S23
STBY
S24
S22
S21
S20
S19
S18
S17
S16
S15
S14
S13
S12
S11
S10
S9
98/S8
P7/S7
P6/S6
P5/S5
P4/S4
P3/S3
P2/S2
P1/S1
C109 100p
C107 100p
BAS
BASS
C108 100p
TRE
TREBLE
NC
S25
DI
L19
BASS-LED2
L18
BASS-LED1
L17
TREBLE-LED2
KEY3
L16
TREBLE-LED1
KEY3
L15
VOL-LED2
KEY2
L14
VOL-LED1
L42
L43
L44
L45
L46
L47
L48
L49
L50
L51
L52
L53
L54
L55
L56
L57
L58
L59
L60
L61
R107 100
L62
INH
L63
R106 100
L64
L65
KEY1
L13
BACKLIGHIT2
L12
BACKLIGHIT1
CE
R108 100
CL
KEY2
R109 100
(Page 44)
DI
KEY1
I-RMC
I-RMC
LCK
LCK
CLK
CLK
DATA
DATA
STBY
~~~~
~~~
STBY
VDD
VDD
VM
GND
GND
GND
VM
C111
0.22
GND
R340
15k
KEY3
CN002
2P
CN003
2P
R341
390
R342
680
R343
1k
R344
1.5k
S344
ENTER
S341
S342
TITLE
DISPLAY
CN009
2P
S343
CN008
2P
MODE
S304
JOG
CN010
3P
CN011
3P
R377
68k
R378
15k
ROTARY ENCODER
MULTI JOG
C371
100p
R376
10k
C370
1000p
R379
180k
C372
100p
R380
10k
61
61
(Page 59)
CX-BK1
8-32. PRINTED WIRING BOARD – ACDC Board –
• Semiconductor
Location
2
3
4
5
:Uses unleaded solder.
6
7
8
9
10
(Page 54)
A
120V
M
ACDC BOARD
S001
VOLTAGE SELECTOR
220V − 230V
240V
-1
-2
JW042
JW041
C123
JW043
Q107
CN003
1
B
JW053
JW051
JW049
JW079
JW052
JW050
13
Q109
R123
JW046
R120
E
R121
E
R147
RED
E
Q106
C122
R148
(US, AEP, UK)
GRN
Q108
R122
JW047
JW048
D004
R119
R118
Q105
W016
JW019
JW044
BLU
JW045
ORG
EP001
D118
A A R138
A
C016
A A
K K
R108
C
R156
R107 R109
R128
R111
R140
(E51)
JW020
(MX)
W017
W013
JW011
R139
K K
R106
R112
R114
R157
JW006
D112
D140
A
(EXCEPT E51)
(EXCEPT E51)
JW022
C124
R113
JW004
R110
GRN
RED
JW018
R116
JW028
D113
K
C015
E
JW005
E
JW007
JW027
D139
K
JW008
R117
JW021
JW026
RY502
BOARD
W PTCN010
(Page 64)
(MX)
BOARD
V PTCN010
(Page 66)
BLU
(E51)
GRN
BOARD
U PTCN008
(Page 66)
YEL
PR005
W014
ORG
1
JW030
JW086
4
JW029
JW025
JW054
JW023
JW055
JW003
-2
-1
W018
PT005 (E51)
PT006 (EXCEPT E51)
POWER TRANSFORMER
(SUB)
RY001
RED
CN011
(E51)
2
BRN
1
W015
(AC IN)
(US)
D
D023
11
JW058
4
K
D006
A
JW024
1
CN004
K
BOARD
J MAINCN007
(Page 43)
JW032
E
C012
D002
JW039
JW037
JW038
JW036
JW001
JW034
JW075
Q103
E
E
R115
JW076
4
JW073
JW060
D007
D008
JW071
JW072
C001
C002
JW061
H
D010
JW087
FH002
D009
(AEP, UK)
PT BOARD
CN001
R
PR001
C004
(US)
I
(Page
64)
F001
Q
JW085
C008
FH001
PT BOARD
CN011
JW080
(Page
64)
C007
(E51, MX)
(Page
66)
PT BOARD
CN015
PT005
BOARD
N AMPCN003
(Page 54)
JW074
G
Q101
E
R102
E
Q104
CN006
1
R101
C003
S
JW064
JW065
CN012
5
1
7
CN009 (AEP, UK)
(US, E51, MX)
JW084
R134
A
JW083
R130
J
R132
K
D117
K
D114
K K
A A
R131
R137
R135
R136
A A
R133
K
D115 A
(AEP, UK)
JW070
D116
K
∗CN009 5PIN CONNECTOR (AEP, UK)
CN012 7PIN CONNECTOR (US, E51, MX)
JW068
JW082
PT006
1
4
1
4
9
5
9
5
C121
JW090
C010
C120
Q102
R103
JW035
(US, E51, MX)
D111
R104
R105
JW091
JW077
F
C029
JW033
C011
YEL
A
D005
JW057
K
62
62
GRN
5
A
JW031
BRN
9
R001
1-688-418-
JW081
E-7
F-6
F-6
F-6
B-6
B-6
B-6
B-6
B-6
AMP BOARD
CN004
(CHASSIS)
JW069
E-3
B-2
D-7
D-7
H-3
H-3
I-3
H-3
D-8
E-6
C-5
C-5
J-5
J-5
J-3
J-2
B-6
C-6
C-6
JW056
Q101
Q102
Q103
Q104
Q105
Q106
Q107
Q108
Q109
12
Location
(E51)
D002
D004
D005
D006
D007
D008
D009
D010
D023
D111
D112
D113
D114
D115
D116
D117
D118
D139
D140
11
RED
Ref. No.
1
• See page 35 for Circuit Boards Location.
(11)
BOARD
T PTCN007
(Page 66)
CX-BK1
8-33. SCHEMATIC DIAGRAM – ACDC Board –
CN006
4P
REG
REG-GND(+7V)
REG-GND(+4V)
JW091
REG-GND(+12V)
JW090
C008
0.1
100V
(Page 53)
(AEP, UK)
D004
CN009
5P
D5SBA20
(US,AEP,UK)
D10XB20
(E51,MX)
CN003
13P
+VH
JW082
VH(AC)
VL(AC)
-VH
C016
∗ C015,016
VH(AC)
∗
3300 63V
(AEP,UK)
3300 71V
(US)
3300 80V
(E51,MX)
+VL
-VL
C015
∗
FAMP-A-GND
VL(AC)
(Page 65)
R104
4.7k
GND
C007
0.1
100V
R101
4.7k
SP-GND
D111
1SS355TE-17
C120
4700p
R105
10k
R113
2.2k
R103
100
R147
39k
Q102-104
R118
100
R148
39k
R119
15k
POWER MINITOR
OVER CURRENT
DETECT
(US)
CN012
7P
JW001
D114
1SS184-TE8
5L
O-POWER
R110
1k
VH(AC)
Q103
2SC3052F-T
1-LF
VH(AC)
VL(AC)
GND
R115
12k
2.7k
(E51,MX)
3.3k
(US)
3.9k
(AEP,UK)
RELAY
REG(AC)
REG(AC)
R106
56k
DRIVE
C004
0.1
100V
Q104
2SA1235TP-1F
D002
D3SBA20
(US,AEP,UK)
(E51,MX)
D5SBA20
(E51,MX)
C121
10
50V
R102
10k
F001
(US)
(E51,MX)
EP001
D008
EGP20DL
6349
D007
EGP20DL
6349
R130 18k
D009
EGP20DL
6349
C002
0.1
100V
VSTBY(+9V)
M-GND
(Page 47)
D112
1SS181-TE8
5L
D113
1SS184-TE8
5L
R140
10k
D118
1SS355TE-1
7
R138
10k
R117
1k
R116
1k
C010
2200
25V
AC DETETC
(CHASSIS)
Q106
2SC3052F-T
1-LF
D116
1SS184-TE8
5L
D117
1SS181-TE8
5L
R139
100k
C124
47
25V
AC DETETC
C001
0.1
100V
(US,E51,MX)
R135 *
R137 82k
R136
10k
R134 82k
∗ R132,135
R132
∗
BRN
CN004
4P
C-LIMITER
TUNER/AUX GND
R131 18k
D010
EGP20DL
6349
R123
33k
VOLTAGE DETECT
Q105
2SA1235TP-1F
(E51)
R121
15k
100V
PR001
DC-DET
Q109
2SC3052F-T
1-LF
Q107-109
D140
1SS181-TE8
5L
C011
∗
4700 35V (US, AEP, UK)
4700 50V (E51, MX)
(Page 53)
RELAY GND
R122
33k
Q108
2SC3052F-T
1-LF
C122
4.7
50V
R114
6.8k
C-LIMITER
R156
5.6k
∗ C011, 012
T5AL 250V
R128
1k
∗
D115
1SS181-TE8
5L
C012
∗
(US, E51, MX)
T5AL 125V
R109
56k
Q107
2SC3052F-T
1-LF
R157
(Page 67)
C003 0.1
R107
56k
C123
0.22
50V
R111
1k
R112
6.8k
D139
1SS184-TE8
5L
(Page 65)
Q102
2SC3052F-T
1-LF
R108
56k
∗ R157
VL(AC)
Q101
2SC3052F-T
1-LF
SP-GND
VM+9V
R120
10k
R133
10k
39k (EXCEPT US)
47k (US)
W018
(E51)
RED
(US)
ORG
W016
(Page 67)
-1
RY502
-2
R001
2.2M
1/2W
JW005
(Page 67)
YEL
W015
JW003
RY001
BLU
D023
1SS355TE-1
7
(E51)
GRN
(EXCEPT E51)
W013
PT005
(EXCEPT E51)
POWER TRANSFORMER
(E51)
(SUB)
(MX)
JW006
JW019
(E51)
W014
RED
W017
D006
1SS181-TE85L
JW007
(Page 67)
(E51)
(E51)
GRN
C029
470
25V
JW008
JW004
(MX)
JW020
(Page 65)
D005
1SS184-TE85L
(US,AEP,UK)
JW018
(E51)
PT006
POWER TRANSFORMER
-1
-2
(EXCEPT E51)
S001
CN011
3P
(SUB)
PR005
VOLTAGE SELECTOR
120V
220-230V
240V
(E51)
(AC IN)
(EXCEPT E51)
63
63
The components identified by mark 0 or dotted
line with mark 0 are critical for safety.
Replace only with part number specified.
CX-BK1
8-34. PRINTED WIRING BOARD – PT Board (US, AEP and UK models) –
PT BOARD
2
:Uses unleaded solder.
(Page 62)
GRN
RED
W ACDC BOARD
• See page 35 for Circuit Boards Location.
CN010
1
∗NOT REPLACEABLE:
BUILT IN TRANSFORMER
1
7
∗
PT003
POWER TRANSFOEMER
(MAIN)
(US)
(US)
JW013
JW014
R
ACDC
BOARD
CN012
(Page 62)
CN001
Q
∗CN001 7PIN CONNECTOR (AEP, UK)
CN011 5PIN CONNECTOR (US)
ACDC
BOARD
CN009
(Page 62)
(AEP, UK)
19
8
C025
CN011
(AEP, UK)
1-688-417-
64
64
12
(12)
CX-BK1
8-35. SCHEMATIC DIAGRAM – PT Board (US, AEP and UK models) –
(AEP, UK)
CN011
5P
PT003
POWER TRANSFORMER
VH(AC)
(MAIN)
VH(AC)
VL(AC)
VL(AC)
GND
(Page 63)
(US)
∗
CN001
7P
VH(AC)
VH(AC)
VL(AC)
CN010
2P
VL(AC)
GRN
GND
RED
REG (AC)
(Page 63)
REG (AC)
(Page 63)
C025
0.47
∗ NOT REPLACEABLE:
BUILT IN TRANSFORMER
The components identified by mark 0 or dotted
line with mark 0 are critical for safety.
Replace only with part number specified.
65
65
CX-BK1
8-36. PRINTED WIRING BOARD – PT Board (Chilean, Peruvian and Mexican models) – • See page 35 for Circuit Boards Location.
:Uses unleaded solder.
PT001
(E51)
YEL
GRN
RED
PT BOARD
U
7
∗
(Page 62)
ACDC BOARD
BLU
(Page 62)
ACDC BOARD
V
1
GRN
(MX)
8
19
∗ NOT REPLACEABLE: BUILT IN TRANSFORMER
PT002
1
2 CN010
3
7
∗
1
CN007
1
3
CN008
BRN
T
19
RED
8
∗ NOT REPLACEABLE: BUILT IN TRANSFORMER
ORG
ACDC
BOARD
(Page 62)
1
7
PT001 (MX)
PT002 (E51)
POWER TRANSFORMER
(MAIN)
JW012
JW013
JW009
CN015
S
ACDC
BOARD
CN012
(Page 62)
19
8
JW014
JW010
C009
11
1-688-421-
66
66
(11)
CX-BK1
8-37. SCHEMATIC DIAGRAM – PT Board (Chilean, Peruvian and Mexican models) –
(E51)
PT002
POWER TRANSFORMER
(MAIN)
JW014
∗
∗ NOT REPLACEABLE:
BUILT IN TRANSFORMER
(MX)
PT001
POWER TRANSFORMER
(MAIN)
CN008
3P
(E51)
BLU
∗
GRN
YEL
(Page 63)
CN007
3P
CN015
7P
ORG
RED
VH(AC)
BRN
VH(AC)
(Page 63)
VL(AC)
VL(AC)
CN010
2P
GND
REG(AC)
(Page 63)
REG(AC)
C009
0.47
GRN
RED
(Page 63)
(MX)
The components identified by mark 0 or dotted
line with mark 0 are critical for safety.
Replace only with part number specified.
67
67
CX-BK1
• IC Block Diagrams
– BD Board –
DVDD2 61
ASYE 62
MD2 63
PVCC/2
NC
VO1-
NC
PVCC1
PVCC1
NC
NC
NC
NC
NC
NC
NC
NC
IN1+
IN1-
OPO1
IN2+
IN2-
OPO2
SGND
52 51 50 49
48
47
46
45
44
43
42
41
40
39
38
37
36
35
34
33
32
31
30
29
NC
54 53
PVCC/2
ASYMMETRY
CORRECTOR
76
77
78
79
80
6
7
8 9 10 11 12 13 14 15 16 17 18 19 20
SCLK
ATSK
WFCK
XUGF
XPCK
GFS
C2PO
SCOR
C4M
WDCK
DVSS0
COUT
MIRR
DATA
5
SENS
4
XLAT
3
CLOK
2
XRST
DVDD0
1
MUTE
CPU
INTERFACE
DIRECTION
DETECTION
31 TFDR
30 SRDR
DIGITAL
CLV
PROCESSOR
25 MDP
24 LOCK
23 PWMI
MIRR, DFCT,
FOK
DETECTOR
22 FOK
21 DFCT
68
68
18
19
20
21
22
23
24
25
26
27
28
SVCC
17
IN3+
16
IN3-
15
OPO3
14
IN4
13
IN4R
VO4+
12
VREF
NC
11
NC
10
NC
9
NC
8
NC
7
NC
6
NC
5
NC
4
NC
3
PVCC2
2
NC
1
PVCC2
RESET CIRCUIT
.STANDBY
.BAND-GAP
.SVCC
29 SFDR
28 DVDD1
27 FSTO
26 SSTP
SERVO INTERFACE
SERVO
AUTO
SEQUENCER
32 TRDR
STANDBY
SUBCODE
PROCESSOR
SOUT 73
SOCK 74
XOLT 75
PVCC/2
33 FFDR
NC
TRACKING
PWM
GENERATOR
SLED
PWM
GENERATOR
DIRECTION
DETECTION
NC
FOCUS
PWM
GENERATOR
VO4-
CLOCK
GENERATOR
FOCUS
SERVO
DSP
TRACKING
SERVO
DSP
SLED
SERVO
DSP
DIRECTION
DETECTION
PGND2
68
69
70
71
72
ERROR
CORRECTOR
SE
TE
VC
TES1
TEST1
DVSS1
FRDR
PGND2
32K
RAM
40
39
38
37
36
35
34
VO3+
EFM
DEMODULATOR
DIRECTION
DETECTION
VO3-
D/A DIGITAL
INTERFACE
A/D
CONVERTER
DIGITAL
OUT
OPERATIONAL
AMPLIFIER &
ANALOG SWITCH
DIGITAL
PLL
LRCK 65
PCMD 66
BCK 67
SQSO
SQCK
SCSY
SBSO
EXCK
55
OSC
DOUT 64
EMPH
XTSL
DVSS2
XTAI
XTAO
56
NC
AVDD0
IGEN
AVSS0
ADIO
RFDC
CE
TE
47 46 45 44 43 42 41
VO1+
AVSS1
RFAC
ASYI
ASYO
51 50 49 48
PGND1
BIAS
AVDD1
PCO
FILI
FILO
CLTV
57 56 55 54 53 52
PGND1
VCTL
59 58
VO2-
V16M
60
AN41020A
VO2+
IC102
CXD3068Q
VPCO
IC101
CX-BK1
IC103
CXA2647N-T4
ROM/RW
A
30 DC OFST
29 RFDCI
–
+
B
–
+
28 RFDC
C
D
VC
VC
VCC
VC
–
+
DVC
VC
ROM/RW
VOFST
27 VC
VC
LD
1
EQ
PD
2
APC AMP
26 RFC
25 VFC
24 BST
RF OFF AT VCC
EQ IN
3
RFAC
VCA
23 RFG
VCC
22 VCC
ROM/RW
AC SUM
GND
RFAC
SUMMING
AMP
4
5
A
A
A
B
C
D
B
C
B
21 CEI
–
+
20 CE
D
C D
DVC
A
B
C
D
6
7
8
9
VOFST
–
+
VC
ROM/RW
19 TE BAL
ROM/RW
E 10
–
+
GM
VC
F 11
–
+
GM
DVC OR Hi-Z
SLEEP, APC OFF
VC
+
–
VOFST
18 TE
VC
ROM/RW
ROM/RW
SW 12
ROM/RW
(L/H)
B
D
DVCC 13
DVC
A
17 FEI
VOFST
–
+
–
+
16 FE
C
DVC 14
DVC
VC
ROM/RW
RFAC 15
69
70
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
VDD
STANDBY
VSS
VSSL
VRAL
LO
VDAL
VDAR
RO
VRAR
VSSR
TESTP
TXO
PO0
PO1
BCKIA 13
SDIO 12
AX
ERAM
2k word
MY
MAC
LRCKIA 14
DAC
Flag
/MIACK 7
YRAM
4k word
Interrupt
Control
1Mbit
SRAM
I-Bus
MIMD 2
SDI1 15
DAC
DRAM I/F
SRAM I/F
PRAM
256 word
SubQ
I/F
Timer
XRAM
4k word
X-Bus
Y-Bus
Program
Control
PROM
1k
=12k word
VC0
CROM
4k word
MX
A0
register
XO • X1 • X2
Y0 • Y1 • Y2
A1
MZ
SDO 9
X-Pointer
register
AY
ALU
A2
Timing
Generator
Address Calc.
2sets
Y-Pointer
register
BCKO 10
10bit
Instruction
Decoder
/MICS 3
A3
VDDT 8
round & limit
MIDIO 5
round & limit
/MILP 4
Microcom. I/F
/RESET 1
General
Output Port
C-Pointer
register
LRCKO 11
Audio I/F
VSSX
XO
XI
VDDX
CKO
VDDP
VCOI
PDO
VSSP
FI2/SBSY
TSTIN/SFSY
PI5/DATA
VDD
PI4/CLCK
PI3
PI2
IC104
LRCKIB
CX-BK1
TC94A20F-CX4
64
63
62
61
60
59
58
57
56
55
54
53
52
51
50
49
General
Input Port
48 VSS
/MICK 6
Bus
Switch
DIT
BCKIB 16
47 PI1
46 PI0
45 VSSM
44 FI1
43 FI0
42 VDDM
41 IRQ
40 VSS
39 MP3REQ
38 PO6
37 PO5
36 PO4
35 VDDT
34 PO3
33 PO2
CX-BK1
– CONNECTOR Board –
– MAIN Board –
IC701, 711, 721
IC501
BA6956AN
TSD
BU4052BCF-E2
16 VDD
2X0
1
2X2
2
2XCOM
3
14 X1
2X3
4
13 XCOM
15 X2
1
2
3
4
5
6
7
8
9
VREF
OUT2
RNF
OUT1
VM
VCC
FIN
GND
RIN
CONTROL LOGIC
INH
6
11 X3
VEE
7
10 A
VSS
8
9
B
SUR2/DPL2
INA2
INB2
INC2
IND2
RECA1/INEX2
RECB2
TMI2
TMO2
TCA2
TCB2
TCC2
TOUT2
VOLIN2
BB A2
BB B2
OUT2
SWOUT
GND
CLOCK
M61529FP-D60G
42 41
40 39 38 37
36
35
34 33
32 31 30
29
28
27
26
25
24
23
22
SUR1/DPL1
IC601
12 X0
2X1 5
TONE CONTROL
(BASS/MID/TREBLE)
ELECTRICAL
VOLUME
INPUT
ATT
BASS
BOOST
TONE ATT
+
+
SURROUND
OR
DPL BUFFER
VOCAL
CUT
MCU
INTERFACE
+
+
TONE ATT
BASS
BOOST
EXTERNAL
INPUT ATT
INPUT
ATT
ELECTRICAL
VOLUME
TONE CONTROL
(BASS/MID/TREBLE)
TMI1
TMO1
TCA1
TCB1
TCC1
16
17
18
19
20
21
VCC
RECB1
15
DATA
RECA1/INEX1
14
OUT1
11 12 13
SAOUT
9 10
BB B1
8
BB A1
7
TOUT1
3 4 5 6
VOLIN1
2
MIC
REF
1
INA1
INB1
INC1
IND1
REF
71
CX-BK1
14
GND
15
GOUT
VREF
17 16
GIN
OUTB
19 18
LINB
HINB
20
LOUTB
INB
HOUTB
IC603 NJM2156M (TE2)
13
12
11
BIAS
+
BBE
+
MACH3
+
1
2
3
4
5
6
7
8
9
10
INA
HINA
HOUTA
LINA
LOUTA
OUTA
BBE
LPOUT
LPIN
V+
BBE
VOUT
MM1614A
VIN
IC905
5
4
CURRENT
LIMITTER
BIAS
REFERENCE
–
+
72
1
2
3
CONT
GND
NOISE
THERMAL
SHUTDOWN
DRIVER
CX-BK1
8-38.
IC PIN FUNCTION DESCRIPTION
• BD BOARD IC101 CXD3068Q (DIGITAL SERVO, DIGITAL SERVO PROCESSOR)
Pin No.
Pin Name
I/O
Description
1
DVDD0
—
2
XRST
I
Reset signal input from the system controller
3
MUTE
I
Muting on/off control signal input terminal
4
DATA
I
Serial data input from the system controller
Power supply terminal (+3.3V) (digital system)
“L”: reset
“H”: muting on
Not used
5
XLAT
I
Serial data latch pulse signal input from the system controller
6
CLOK
I
Serial data transfer clock signal input from the system controller
7
SENS
O
Internal status (SENSE) signal output to the system controller
8
SCLK
I
SENSE serial data reading clock signal input from the system controller
9
ATSK
I/O
Input/output terminal for anti-shock
10
WFCK
O
Write frame clock signal output terminal
11
RFCK
O
RFCK signal output terminal
Not used
12
XPCK
O
XPCK signal output terminal
Not used
13
GFS
O
Guard frame sync signal output terminal
14
C2PO
O
C2 pointer signal output terminal
15
SCOR
O
Subcode sync (S0+S1) detection signal output to the system controller
16
C4M
O
4.2336 MHz clock signal output terminal
17
WDCK
O
Guard subcode sync (S0+S1) detection signal output terminal
18
DVSS0
—
Ground terminal (digital system)
19
COUT
O
Numbers of track counted signal output terminal
20
MIRR
O
Mirror signal output terminal
21
DFCT
I/O
Defect signal input/output terminal
22
FOK
O
Focus OK signal output terminal
23
PWMI
I
Spindle motor external control signal input terminal
24
LOCK
O
GFS is sampled by 460 Hz
25
MDP
O
Spindle motor servo drive signal output to the motor/coil drive IC
Not used
Not used
Not used
Not used
Not used
Not used
Not used
Not used
Not used
Not used
Not used
“H” output when GFS is “H”
26
SSTP
I
Detection signal input from limit in switch
27
FSTO
O
2/3 divider output terminal
28
DVDD1
—
Power supply terminal (+3.3V) (digital system)
29
SFDR
O
Sled servo drive PWM signal (+) output terminal
30
SRDR
O
Sled servo drive PWM signal (–) output terminal
31
TFDR
O
Tracking servo drive PWM signal (+) output terminal
32
TRDR
O
Tracking servo drive PWM signal (–) output terminal
33
FFDR
O
Focus servo drive PWM signal (+) output terminal
Not used
The optical pick-up is inner position when “H”
Not used
34
FRDR
O
Focus servo drive PWM signal (–) output terminal
35
DVSS1
—
Ground terminal (digital system)
36
TEST
I
Input terminal for the test
37
TES1
I
Input terminal for the test
38
VC
I
Middle point voltage (+1.65V) input terminal
39
FE
I
Focus error signal input from the RF amplifier
40
SE
I
Sled error signal input from the RF amplifier
41
TE
I
Tracking error signal input from the RF amplifier
42
CE
I
Middle point servo analog signal input
43
RFDC
I
RF signal input from the RF amplifier
44
ADIO
O
Output terminal for the test
45
AVSS0
—
Ground terminal (analog system)
Not used
73
CX-BK1
Pin No.
Pin Name
I/O
46
IGEN
I
47
AVDD0
—
Power supply terminal (+3.3V) (analog system)
48
ASYO
O
EFM full-swing output terminal
49
ASYI
I
Asymmetry comparator voltage input terminal
50
RFAC
I
EFM signal input from the RF amplifier
51
AVSS1
—
52
CLTV
I
Internal VCO control voltage input terminal
53
FILO
O
Filter output for master PLL
54
FILI
I
Filter input for master PLL
74
Description
Stabilized current input for operational amplifiers
Ground terminal (analog system)
55
PCO
O
Charge pump output for master PLL
56
AVDD1
—
Power supply terminal (+3.3V) (analog system)
57
BIAS
I
Asymmetry circuit constant current input terminal
58
VCTL
I
VCO control voltage input terminal for the wideband EFM PLL Not used
59
V16M
O
VCO oscillation output terminal for the wideband EFM PLL Not used
60
VPCO
O
Charge pump output terminal for the wideband EFM PLL Not used
61
DVDD2
—
Power supply terminal (+3.3V) (digital system)
62
ASYE
I
Asymmetry circuit on/off control signal input terminal “L”: off, “H”: on Not used
63
MD2
I
Digital out on/off control signal input terminal
“L”: digital out off, “H”: digital out on Fixed at “H” in this set
64
DOUT
O
Digital audio signal output terminal
65
LRCK
O
L/R sampling clock signal (44.1 kHz) output to the MP3 decoder
66
PCMD
O
Serial data output to the MP3 decoder
67
BCLK
O
Bit clock signal (2.8224 MHz) output to the MP3 decoder
68
EMPH
O
“L” is output when playback disc is emphasis off
“H” is output when playback disc is emphasis on Not used
69
XTSL
I
Input terminal for the system clock frequency setting
“L”: 16.9344 MHz, “H”: 33.8688MHz Fixed at “H” in this set
70
DVSS2
—
Ground terminal (digital system)
71
XTAI
I
System clock input terminal (33.8688 MHz)
72
XTAO
O
System clock output terminal (33.8688 MHz) Not used
73
SOUT
O
Serial data output terminal Not used
74
SOCK
O
Serial data reading clock signal output terminal Not used
75
XOLT
O
Serial data latch pulse signal output terminal Not used
76
SQSO
O
Subcode Q data output to the system controller
77
SQCK
I
Subcode Q data reading clock signal input from the system controller
78
SCSY
I
Input terminal for resynchronism of guard subcode sync (S0+S1) Not used
79
SBSO
O
Subcode serial data output terminal Not used
80
EXCK
I
Subcode serial data reading clock signal input terminal Not used
CX-BK1
• MAIN BOARD IC901 uPD703260YGF-S04-JBT-A (SYSTEM CONTROLLER)
Pin No.
Pin Name
I/O
Description
1
RDS_SIG
I
Tuning signal level input from the RDS decoder
2
RDS_DATA
I
Serial data input from the RDS decoder
3
AVREF0
—
Reference voltage (+3.1V) input terminal
4
AVSS
—
Ground terminal
5
MICS
O
Chip select signal output to the MP3 decoder
Serial data input from the tuner unit
Used for the AEP, UK models
Used for the AEP, UK models
6
DO
I
7
AVREF1
—
8
STEREO
I
Stereo detection signal input from the tuner unit
9
TUNE
I
Tuner tuned status signal from the tuner unit
10
FLMD0
—
Not used
11
VDD
—
Power supply terminal (+3.1V)
12
REGC
—
Connected to the external capacitor
13
VSS
—
Ground terminal
14
X1
I
Main system clock input terminal (5MHz)
15
X2
O
Main system clock output terminal (5MHz)
16
RESET
I
Reset signal input from the reset signal generator
17
XT1
I
Sub system clock input terminal (32.768kHz)
18
XT2
O
Sub system clock output terminal (32.768kHz)
19
MP3RST
O
System reset signal output to the MP3 decoder
20
RDS_CLK
I
Clock signal input from the RDS decoder
Microphone detect signal input terminal
Used for the AEP, UK, Chilean, Peruvian models
21
SCOR
I
SCOR signal input from the digital signal processor
22
CAN'T_USE
—
23
RMC
I
24
USB_DATA
I/O
I2C data input/output with the USB interface IC
25
USB_CLK
I/O
I2C clock signal input/output to the USB interface IC
26
DECK_PLAYSW
I
PLAY switch signal input from the tape mechanism deck
27
DECK_ENDSW
I
END switch signal input from the tape mechanism deck
28
DECK_PACK
I
PACK switch signal input from the tape mechanism deck
Power supply terminal (+3.1V)
“L”: reset
Not used
Remote control signal input from the remote control receiver
29
DECK_FREC
I
Record protect detect switch signal input from the tape mechanism deck (front)
30
DECK_RREC
I
Record protect detect switch signal input from the tape mechanism deck (rear)
31
USB_ACK
I
Acknowledge signal input from the USB interface IC
32
USB_INT
I
Interrupt request signal input from the USB interface IC
33
USB_VBUS_ON
O
VBUS control signal output terminal
34
STBY
O
Standby LED control signal output terminal
35
EVSS
—
Ground terminal
36
EVDD
—
37
MIACK
I
Acknowledge signal input from the MP3 decoder
38
MP3STB
O
Strobe signal output to the MP3 decoder
39
MUTE
O
Muting control signal output to power amplifier circuit
40
POWER
O
Main power control signal output terminal
41
POWER_DOWN
I
Power down detection signal input terminal
42
HEADPHONE
I
Headphone detection signal input
43
SHIFT_CLK
O
Serial data transfer clock signal output to the shift register
Power supply terminal (+3.1V)
“L”: headphone on
75
CX-BK1
Pin No.
Pin Name
I/O
44
SHIFT_DATA
O
Serial data output to the shift register
45
SHIFT_STB
O
Strobe signal output to the shift register
46
PLLCE
O
Latch signal output to the tuner unit
47
PWM1
O
PWM signal output for focus offset adjustment
48
MCLK
O
Serial data transfer clock signal output to the tuner unit and input select IC
49
PWM3
O
PWM signal output for RF offset adjustment
50
MDATA
O
Serial data output to the tuner unit and input select IC
51
PWM2
O
PWM signal output for tracking offset adjustment
52
DATA
O
Serial data output to the digital signal processor
53
LCD_DATA
O
Serial data output to the LCD driver
54
LCD_CLK
O
Serial data transfer clock output to the LCD driver
55
CLOCK
O
Serial data transfer clock output to the digital signal processor
56
SQSO
I
Sub-Q data input from the digital signal processor
57
SQCK
O
Sub-Q clock output to the digital signal processor
58
SENS
I
SENS signal input from the digital signal processor
59
LDON
O
Laser diode on/off control signal output to the automatic power control circuit “H”: laser on
60
XLT
O
Control data latch signal output to the digital signal processor
61
XRST
O
System reset signal output to the digital signal processor and motor/coil drive IC
62
MICK
O
Serial data transfer clock signal output to the MP3 decoder
63
LCD_CE
O
Latch signal output to the LCD driver
64
MIDIO
I/O
Serial data input/output to/form the MP3 decoder
65
MP3REQ
O
Request signal output to the MP3 decoder
66
MILP
O
Latch pulse signal output to the MP3 decoder
67
ELV_E2
I
ELV_E2 switch signal input from the CD mechanism
68
ELV_E3
I
ELV_E3 switch signal input from the CD mechanism
69
ELV_E1
I
ELV_E1 switch signal input from the CD mechanism
70
SLD_E3
I
SLD_E3 switch signal input from the CD mechanism
71
BVSS
—
Ground terminal
72
BVDD
—
Power supply terminal
73
SLD_E1
I
SLD_E1 switch signal input from the CD mechanism
76
Description
74
SW5-B
I
SW4 switch signal input from the CD mechanism
75
ELV_POS
O
Elevator motor control signal output for the CD mechanism
76
SLD_POS
O
Loading motor control signal output for the CD mechanism
77
LOD_POS
O
Sled motor control signal output for the CD mechanism
78
SW4
I
SW5-B switch signal input from the CD mechanism
79
SW2-A
I
SW2-A switch signal input from the CD mechanism
80
SW3
I
SW3 switch signal input from the CD mechanism
81
D_SENSOR
I
Disc sensor signal input from the CD mechanism
82
SW1-A
I
SW1-A switch signal input from the CD mechanism
83
SW2-B
I
SW2-B switch signal input from the CD mechanism
84
SW5-A
I
SW5-A switch signal input from the CD mechanism
85
LOD_NEG
O
Sled motor control signal output for the CD mechanism
86
SLD_NEG
O
Loading motor control signal output for the CD mechanism
87
ELV_NEG
O
Elevator motor control signal output for the CD mechanism
88
SLD_E0
I
SLD_E0 switch signal input from the CD mechanism
89
SLD_E2
I
SLD_E2 switch signal input from the CD mechanism
CX-BK1
Pin No.
Pin Name
I/O
Description
90
ELV_E0
I
ELV_E0 switch signal input from the CD mechanism
91
RE_TRE
I
Jog dial pulse input from the rotary encoder (TREBLE/MIDDLE)
92
RE_BAS
I
Jog dial pulse input from the rotary encoder (BASS)
93
RE_VOL
I
Jog dial pulse input from the rotary encoder (VOLUME)
94
RE_JOG
I
Jog dial pulse input from the rotary encoder (MULTIJOG)
95
KEY3
I
Key input terminal (A/D input)
96
KEY2
I
Key input terminal (A/D input)
97
KEY1
I
Key input terminal (A/D input)
98
POWER_MONI
I
Voltage detection signal input terminal
99
LEVEL
I
Level mater signal input terminal
100
SUFIX
I
Destination setting input terminal
77
CX-BK1
• USB AUX BOARD IC700 uAC3553B (USB INTERFACE)
Pin No.
Pin Name
I/O
Description
1
XTI
I
System clock input terminal (12MHz)
2
XTO
O
System clock output terminal (12MHz)
3
AREG1
I
Connected to the external capacitor
4
AVSS_12
—
Ground terminal
5
OUTL
O
USB audio signal output terminal (L-ch)
6
OUTR
O
USB audio signal output terminal (R-ch)
7
AREG0
I
Connected to the external capacitor
8
AVDD
—
9
DAI
I
Not used
10
WSI
I
Not used
11
CLI
I
Not used
12
INT_DATA
O
Interrupt request signal output to the USB interface IC
13
ACK
O
Acknowledge signal output to the USB interface IC
14 to 19
NC
—
Not used
20
SDA
I/O
I2C data input/output with the system controller
21
SCL
I/O
I2C clock signal input/output to the system controller
22
TRDY
I
Not used
23
VREG
I
Connected to the external capacitor
24
VBUS
I
USB connect detection signal input terminal
25
D–
I
USB data (–) input terminal
26
D+
I
Power supply terminal (+5V)
USB data (+) input terminal
27
VSS
—
Ground terminal
28
VDD
—
Power supply terminal (+5V)
29
TEST
I
For test terminal
30
REST
I
Not used
31
SUSPEND
I
Not used
32
SOF
I
Not used
33
SEN
I
Not used
34
FOUTL
O
USB audio signal output terminal (L-ch)
35
FOPL
I
Not used
36
FINL
O
USB audio signal input terminal (L-ch)
37
FOUTR
O
USB audio signal output terminal (R-ch)
38
FOPR
I
Not used
39
FINR
O
USB audio signal input terminal (R-ch)
40, 41
NC
—
Not used
42
SGND
—
Ground terminal
43
SREF
I
Not used
44
NC
I
Not used
78
CX-BK1
SECTION 9
EXPLODED VIEWS
NOTE:
• -XX and -X mean standardized parts, so they
may have some difference from the original
one.
• Color Indication of Appearance Parts
Example:
KNOB, BALANCE (WHITE) . . . (RED)
↑
↑
Parts Color Cabinet's Color
• Items marked “*” are not stocked since they
are seldom required for routine service. Some
delay should be anticipated when ordering
these items.
• The mechanical parts with no reference number in the exploded views are not supplied.
• Tape deck is not loaded in US model.
The shape of the top panel shown in “EXPLODED VIEWS” is different from the actual shape.
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
• Abbreviation
E51 : Chilean and Peruvian models
MX : Mexican model
9-1. PANEL SECTION
#1
#1
top panel block
3
5
4
#1
#1
chassis block-1
M301
#1
1
2
2
front panel block-1
#1
Ref. No.
Part No.
Description
1
1
2
3
3
4-245-038-01
4-245-038-11
4-242-531-01
4-245-073-01
4-245-073-11
PANEL, RIGHT (US)
PANEL, RIGHT (AEP, UK, E51, MX)
QT2+3-10 TYPE2 IT-3
PANEL (LEFT) (US)
PANEL (LEFT) (AEP, UK, E51, MX)
4
4-245-039-01 COVER, REAR (US)
#1
Remark
Ref. No.
Part No.
Description
4
4
4
5
M301
4-245-039-11
4-245-039-21
4-245-039-31
4-951-620-01
1-763-072-11
COVER, REAR (E51)
COVER, REAR (AEP, UK)
COVER, REAR (MX)
SCREW (2.6X8), +BVTP
FAN, DC
#1
7-685-647-79 SCREW +BVTP 3X10 TYPE2 IT-3
Remark
79
CX-BK1
9-2. TOP PANEL BLOCK
Note: Tape deck is not loaded in US model.
The shape of the top panel shown in “EXPLODED VIEWS” is
different from the actual shape.
57
58
not
supplied
59
56
#1
not supplied
not supplied
#1
#1
51
54
#1
55
53
52
#1
60
Ref. No.
51
Part No.
Description
Remark
52
53
54
55
1-796-351-61 MECHANISM, SIGNAL CASSETTE
(CMAL1Z241A) (EXCEPT US)
4-242-174-01 HLDR, LOCK 1 (EXCEPT US)
4-242-173-01 SPR-C, LOCK (EXCEPT US)
4-242-171-01 DAMPER 150 N (EXCEPT US)
4-242-172-01 PLATE, LOCK (EXCEPT US)
56
4-247-458-01 SPRING (CASS), TORSION (EXCEPT US)
80
Ref. No.
Part No.
Description
Remark
57
57
58
59
60
4-245-072-01
4-245-072-11
A-4733-420-A
1-765-326-11
1-827-677-11
PANEL, TOP (US)
PANEL, TOP (EXCEPT US)
DECK BOARD, COMPLETE (EXCEPT US)
WIRE (FLAT TYPE) (11 CORE) (EXCEPT US)
WIRE (FLAT TYPE) (8 CORE) (EXCEPT US)
#1
7-685-647-79 SCREW +BVTP 3X10 TYPE2 IT-3
CX-BK1
9-3. FRONT PANEL BLOCK-1
104
#1
not supplied
#1
106
#1
#1
103
not supplied
(LED board)
105
107
102
#1
front panel block-2
101
Ref. No.
101
102
103
104
Part No.
Description
Remark
A-4733-419-A
1-769-869-11
1-688-414-11
1-688-407-11
MIC BOARD, COMPLETE (E51, MX)
WIRE (FLAT TYPE) (5 CORE) (E51, MX)
HEADPHONE BOARD
LEFT BUTTON BOARD
Ref. No.
105
106
107
#1
Part No.
Description
A-4733-395-A
A-4733-399-A
3-229-336-01
7-685-647-79
KEY LED RMC BOARD, COMPLETE
USB AUX BOARD, COMPLETE
SCREW, +BVWH TAPPING
SCREW +BVTP 3X10 TYPE2 IT-3
Remark
81
CX-BK1
9-4. FRONT PANEL BLOCK-2
#1
153
155
#1
156
154
not supplied
front panel block-3
#1
157
152
#1
158
160
151
159
161
Ref. No.
Part No.
Description
151
152
153
154
155
X-4955-595-1
X-4955-596-1
1-773-115-11
1-773-156-11
A-4733-394-A
VOL ASSY, KNOB RTRY
TRE ASSY, KNOB RTRY
WIRE (FLAT TYPE) (19 CORE)
WIRE (FLAT TYPE) (21 CORE)
LCD VOL BOARD, COMPLETE
156
1-688-413-11 JOG BOARD
82
Remark
Ref. No.
Part No.
Description
157
158
159
160
161
4-245-101-01
1-688-408-11
1-688-409-11
4-242-531-01
4-245-089-01
KNOB (JOG), ROTARY
RIGHT BUTTON (1) BOARD
RIGHT BUTTON (2) BOARD
QT2+3-10 TYPE2 IT-3
KNOB (MIC), ROTARY (E51, MX)
#1
7-685-647-79 SCREW +BVTP 3X10 TYPE2 IT-3
Remark
CX-BK1
9-5. FRONT PANEL BLOCK-3
not supplied
205
214
206
204
202
203
207
213
209
not supplied
208
211
212
210
201
Ref. No.
Part No.
Description
201
201
201
202
202
X-4955-409-2
X-4955-727-2
X-4955-728-2
4-245-075-01
4-245-075-11
CABI, FR ASSY (US)
CABINET (FRONT) ASSY (E51, MX)
CABINET (FRONT) ASSY (AEP, UK)
PANEL, FRONT (US)
PANEL, FRONT (AEP, UK, E51, MX)
203
204
205
206
X-4955-408-1
4-245-098-01
4-245-078-01
4-242-531-01
PANEL,DISP ASSY
REFLECTOR (VOL)
WINDOW, DISPLAY
QT2+3-10 TYPE2 IT-3
Remark
Ref. No.
Part No.
Description
207
208
209
210
211
4-245-088-01
4-245-094-01
4-245-158-01
4-245-077-01
4-242-091-01
WINDOW, SENSOR
PANEL, CD DIRECT
EMBLEM
PANEL (JOB)
CUSHION
212
213
214
#1
4-246-682-01
4-250-402-01
2-249-914-01
7-685-647-79
EMBLEM (30), MP3
SPRING (PANEL), GROUND
SHEET, INSULATED
SCREW +BVTP 3X10 TYPE2 IT-3
Remark
83
CX-BK1
9-6. CHASSIS BLOCK-1
254
255
258
257
not supplied
#7
#1
#1
253
#1
252
259
256
#1
251
chassis block-2
PT001 (MX)
PT002 (E51)
PT003 (US, AEP, UK)
not supplied
The components identified by mark 0 or dotted
line with mark 0 are critical for safety.
Replace only with part number specified.
Part No.
Description
Ref. No.
Part No.
Description
251
251
252
253
253
1-688-417-11
1-688-421-11
4-242-527-01
A-4733-389-A
A-4733-423-A
PT BOARD (US, AEP, UK)
PT BOARD (E51, MX)
S-SCREW, ITC+4-8 R
MAIN BOARD, COMPLETE (US)
MAIN BOARD, COMPLETE (E51, MX)
257
257
258
259
0 PT001
1-693-626-11
1-693-628-11
1-769-944-11
4-242-519-01
1-439-796-11
TUNER (FM/AM) (AEP, UK)
TUNER (FM/AM) (E51, MX)
WIRE (FLAT TYPE) (11 CORE)
BVT2+3-6 W/O SLOT
TRANSFORMER, POWER (MX)
253
254
255
255
256
A-4733-440-A
1-765-334-11
1-769-943-11
1-773-007-11
1-688-419-11
MAIN BOARD, COMPLETE (AEP, UK)
WIRE (FLAT TYPE) (17 CORE)
WIRE (FLAT TYPE) (11 CORE) (US, E51, MX)
WIRE (FLAT TYPE) (15 CORE) (AEP, UK)
SPEAKER BOARD
0 PT002
0 PT003
0 PT003
#1
#7
1-439-795-11
1-439-794-11
1-439-797-11
7-685-647-79
7-685-646-79
TRANSFORMER, POWER (E51)
TRANSFORMER, POWER (US)
TRANSFORMER, POWER (AEP, UK)
SCREW +BVTP 3X10 TYPE2 IT-3
SCREW +BVTP 3X8 TYPE2 IT-3
257
1-693-625-11 TUNER (FM/AM) (US)
Ref. No.
84
Remark
Remark
CX-BK1
9-7. CHASSIS BLOCK-2
not supplied
#2
#1
#1
301
304
#1
303
not supplied
#1
Q534
#1
Q532
F001
Q533
302
Q531
#1
#1
#1
#1
not supplied
CD mechanism deck section-1
not supplied
#1
not supplied
(CD support board)
#1
305
not supplied
not supplied
305
not supplied
306
Ref. No.
Part No.
Description
Remark
301
301
301
301
* 302
A-4733-391-A
A-4733-418-A
A-4733-430-A
A-4733-432-A
3-703-244-00
ACDC BOARD, COMPLETE (US)
ACDC BOARD, COMPLETE (E51)
ACDC BOARD, COMPLETE (MX)
ACDC BOARD, COMPLETE (AEP, UK)
BUSHING (2104), CORD (US, AEP, UK, E51)
302
0 303
0 303
0 303
304
3-703-571-11
1-777-071-83
1-783-532-11
1-827-226-11
A-4733-393-A
BUSHING (S) (4516), CORD (MX)
CORD, POWER (AEP, UK, E51)
CORD, POWER (US)
CORD, POWER (MX)
AMP BOARD, COMPLETE (US)
304
304
305
306
0 F001
A-4733-415-A
A-4733-434-A
4-242-530-01
4-242-091-01
1-533-453-12
AMP BOARD, COMPLETE (E51, MX)
AMP BOARD, COMPLETE (AEP, UK)
QT2+3-8 W/O SLOT
CUSHION
FUSE, GLASS TUBE (DIA. 5) (5A/125V) (US)
The components identified by mark 0 or dotted
line with mark 0 are critical for safety.
Replace only with part number specified.
Ref. No.
Part No.
Description
Remark
0 F001
Q531
Q531
Q531
Q532
1-533-472-11 FUSE, GLASS TUBE (DIA. 5) (5A/250V)
(E51, MX)
6-550-291-01 TRANSISTOR FN1016 (AEP, UK)
6-550-320-01 TRANSISTOR 2SD2562 (E51, MX)
8-729-020-52 TRANSISTOR 2SD2439-OPY (US)
6-550-291-01 TRANSISTOR FN1016 (AEP, UK)
Q532
Q532
Q533
Q533
Q533
6-550-320-01
8-729-020-52
6-550-292-01
6-550-319-01
8-729-020-48
TRANSISTOR 2SD2562 (E51, MX)
TRANSISTOR 2SD2439-OPY (US)
TRANSISTOR FP1016 (AEP, UK)
TRANSISTOR 2SB1649 (E51, MX)
TRANSISTOR 2SB1588-OPY (US)
Q534
Q534
Q534
#1
#2
6-550-292-01
6-550-319-01
8-729-020-48
7-685-647-79
7-685-648-79
TRANSISTOR FP1016 (AEP, UK)
TRANSISTOR 2SB1649 (E51, MX)
TRANSISTOR 2SB1588-OPY (US)
SCREW +BVTP 3X10 TYPE2 IT-3
SCREW +BVTP 3X12 TYPE2 IT-3
85
CX-BK1
9-8.
CD MECHANISM DECK SECTION-1 (CDM69BV-30CBD64NS)
not supplied
504
502
#4
501
S702
#4
513
#4
M761
506
503
502
not supplied
(ST encorder board)
508
CD mechanism deck section-2
509
507
502
510
#4
Ref. No.
Part No.
Description
501
502
503
504
506
1-686-725-12
4-951-620-01
4-239-690-01
4-239-618-01
4-239-687-01
STOCKER MOTOR BOARD
SCREW (2.6X8), +BVTP
CAM (STOCKER U/D)
SCREW (+PWH,2X6), STEP TAPPING
GEAR (STOCKER COMMUNICATION)
507
508
A-4731-113-A CONNECTOR BOARD, COMPLETE
4-239-689-01 GEAR (STOCKER DECELERATION)
86
Remark
Ref. No.
Part No.
Description
509
510
513
M761
S702
4-239-683-01
4-221-273-01
4-244-764-01
A-4735-953-A
1-477-299-11
PULLEY (MODE DECELERATION)
BELT (MODE)
CAM (STOCKER V)
MOTOR ASSY (STOCKER)
ENCODER, ROTARY (STOCKER POSITION)
Remark
#4
7-685-902-21 SCREW +PTPWH 2.6X8 (TYPE2)
CX-BK1
9-9.
CD MECHANISM DECK SECTION-2 (CDM69BV-30CBD64NS)
553
554
552
555
#5
555
551
CD mechanism deck section-3
557
CD mechanism deck section-5
560
561
556
559
560
560
559
559
560
optical pick-up
section
559
558
Ref. No.
Part No.
Description
551
552
553
554
555
1-686-727-12
1-686-728-12
1-686-729-12
1-686-730-12
4-951-620-01
SW (1) BOARD
SW (2) BOARD
SW (3) BOARD
SW (4) BOARD
SCREW (2.6X8), +BVTP
556
4-985-672-01 SCREW (+PTPWHM 2.6), FLOATING
Remark
Ref. No.
Part No.
Description
557
558
559
560
261
4-227-899-01
4-243-716-01
4-234-824-01
4-985-672-01
4-244-960-02
SCREW (DIA,12), FLOATING
HOLDER (BU-30)
RUBBER, VIBRATION PROOF
SCREW (+PTPWHM2.6), FLOATING
SPRING (BU30-1), TENSION
#5
7-685-533-14 SCREW +BTP 2.6X6 TYPE2 N-S
Remark
87
CX-BK1
9-10. CD MECHANISM DECK SECTION-3 (CDM69BV-30CBD64NS)
607
not supplied
606
not
supplied
not supplied
605
609
622
610
not
supplied
611
620
609
608
615
602
613
612
not
supplied
605
614
615
617
616
623
not supplied
604
618
603
604
624
602
602
618
621
602
618
619
618
601
602
Ref. No.
Part No.
Description
601
602
603
604
605
X-4955-447-1
4-992-069-01
4-239-648-01
4-239-646-01
4-239-641-01
PULLEY (A)(BU30) ASSY,CHUCKING
SCREW (+PTPWH) (M2) (DIA. 7)
PARASOL (ROLLER)
ROLLER (ROLLER)
SPRING (1.2), TENSION
606
607
608
609
610
4-239-642-01
4-239-679-01
4-243-714-01
4-239-649-01
4-240-040-01
SPRING (3), TENSION COIL
SPRING (5), TENSION COIL
PULLEY (B) (BU30), CHUCKING
PARASOL (STOCKER)
SPRING (DISC STOPPER), TORSION
611
612
4-244-035-01 ROLLER (STOCKER), RUBBER
4-239-640-01 PINION (SLIDER)
88
Remark
Ref. No.
Part No.
Description
613
614
615
616
617
4-243-291-01
4-240-039-01
4-239-702-01
4-985-672-01
4-243-713-01
SPRING, TORSION
LEVER (DISC STOPPER)
ROLLER (DISC STOPPER)
SCREW (+PTPWHM2.6), FLOATING
LEVER (LIFTER)
618
619
620
621
622
4-239-647-01
4-243-916-01
4-241-599-01
4-228-414-01
4-239-643-01
PARASOL (MAIN)
ROLLER (S), RUBBER
LEVER (SUPPORT)
BRACKET (YOKE)
SPRING (4), TENSION COIL
623
624
4-243-914-01 SPRING (LIFTER), TORSION
4-244-032-01 ROLLER, RUBBER
Remark
CX-BK1
9-11. CD MECHANISM DECK SECTION-4 (CDM69BV-30CBD64NS)
#6
657
#6
657
658
654
657
654
667
657
653
656
655
655
#6
657
657
652
658
670
#6
658
656
654
651
652
657
655
656
663
661
675
661
652
661
666
657
651
661
673
656
655
664
653
not
supplied
665
657
658
670
671
662
#6
669
668
653
656
#6
660
666
655
672
654
653
652
M781
651
CD mechanism deck section-5
Ref. No.
Part No.
Description
Part No.
Description
651
652
653
654
655
X-4954-626-1
4-239-666-01
4-239-668-01
4-239-652-01
4-239-669-01
LEVER (ROLLER) ASSY
GEAR
LEVER (CENTER)
SCREW (ROLLER), STEP
GEAR (ROLLER COMMUNICATION)
Remark
Ref. No.
665
666
667
668
669
4-240-041-01
4-951-620-01
4-243-916-01
4-244-035-01
4-241-209-01
SPRING (SLIDER 2), TENSION
SCREW (2.6X8), +BVTP
ROLLER (S), RUBBER
ROLLER (STOCKER), RUBBER
SHEET, ADHESIVE
656
657
658
660
661
4-239-667-01
4-239-647-01
4-244-032-01
X-4954-622-1
4-239-670-01
GEAR (ROLLER CENTER)
PARASOL (MAIN)
ROLLER, RUBBER
BASE (SLIDER 2) ASSY
GEAR (ROLLER 5 COMMUNICATION)
670
671
672
673
675
4-239-649-01
4-239-671-01
X-4954-627-1
1-686-726-12
4-244-162-01
PARASOL (STOCKER)
GEAR (ROLLER 5 CENTER)
BASE (SLIDER 5) ASSY
ROLLER MOTOR BOARD
SPRING (SLIDER 4),TENSION
662
663
664
X-4954-624-A LEVER (SLIDER 4) ASSY
4-992-069-01 SCREW (+PTPWH)(M2)(DIA. 7)
4-240-981-01 SPRING (BASE SLIDER 5),TENSION
M781
#6
A-4735-953-A MOTOR ASSY (ROLLER)
7-623-921-01 WASHER 1.7, NYLON
Remark
89
CX-BK1
9-12. CD MECHANISM DECK SECTION-5 (CDM69BV-30CBD64NS)
704
703
705
703
705
701
702
706
CD mechanism deck section-6
707
709
708
Ref. No.
701
702
703
704
705
90
Part No.
Description
4-240-020-01
4-239-708-02
4-239-697-01
X-4955-157-1
4-239-706-02
GEAR (TIMING)
BELT (FRONT), TIMING
GEAR (CENTER)
SLIDER (MODE CAM V) ASSY
BELT (REAR), TIMING
Remark
Ref. No.
706
707
708
709
#4
#4
Part No.
Description
4-239-699-01
4-247-349-02
4-227-899-01
4-239-686-01
7-685-902-21
PULLEY
BELT (ROLLER V)
SCREW (DIA. 12), FLOATING
GEAR (ROLLER DECELERATION)
SCREW +PTPWH 2.6X8 (TYPE2)
Remark
CX-BK1
9-13. CD MECHANISM DECK SECTION-6 (CDM69BV-30CBD64NS)
763
775
not supplied
765
M771
751
#4
#4
754
#4
#4
753
769
#4
764
755
755
758
760
not
supplied
770
757
#4
772 762
763
759
752
767
763
763
#4
#4
S771
761
771
766
#4
#4
Ref. No.
Part No.
Description
Part No.
Description
751
752
753
754
755
4-239-693-02
1-686-723-12
4-239-696-01
4-239-695-02
4-240-019-01
CAM (GEAR)
SENSOR BOARD
GEAR (EJECT LOCK)
CAM (EJECT LOCK)
GEAR (MODE 5)
Remark
Ref. No.
764
765
766
767
769
4-239-692-02
4-239-694-01
4-241-731-01
4-241-732-01
4-241-734-01
CAM (BU U/D)
GEAR (MODE CAM)
SHUTTER (A), LEVER
SHUTTER (B), LEVER
SHAFT (SHUTTER)
757
758
759
760
761
4-243-682-01
4-239-683-01
4-243-702-01
4-243-683-01
4-239-618-01
GEAR (MODE C)
PULLEY (MODE DECELERATION)
BELT (MODE V)
GEAR (MODE D)
SCREW (+PWH,2X6), STEP TAPPING
770
771
772
775
M771
4-241-735-01
4-685-672-01
4-243-680-01
1-686-724-12
A-4735-953-A
SPRING (SHUTTER), COMPRESSION
SCREW (DIA. 12), FLOATING
GEAR (MODE A)
MODE MOTOR BOARD
MOTOR ASSY (MODE)
762
763
4-243-681-01 GEAR (MODE B)
4-951-620-01 SCREW (2.6X8), +BVTP
S771
#4
1-477-300-11 ENCODER, ROTARY (MODE)
7-685-902-21 SCREW +PTPWH 2.6X8 (TYPE2)
Remark
91
CX-BK1
9-14. OPTICAL PICK-UP SECTION
(BU-30CBD64NS)
808
807
801
803
802
The components identified by mark 0 or dotted
line with mark 0 are critical for safety.
Replace only with part number specified.
Ref. No.
801
802
803
92
Part No.
Description
4-236-304-02 SPRING (SLED), LEAF
A-4731-674-A BD BOARD, COMPLETE
3-372-761-01 SCREW (M1.7), TAPING
Remark
Ref. No.
Part No.
Description
0 807
808
A-4735-189-A BU-30 (61) ASSY
1-782-817-11 WIRE (FLAT TYPE)(16 CORE)
Remark
CX-BK1
SECTION 10
ELECTRICAL PARTS LIST
NOTE:
• Due to standardization, replacements in the
parts list may be different from the parts specified in the diagrams or the components used
on the set.
• -XX and -X mean standardized parts, so they
may have some difference from the original
one.
• RESISTORS
All resistors are in ohms.
METAL: Metal-film resistor.
METAL OXIDE: Metal oxide-film resistor.
F: nonflammable
• Abbreviation
E51 :Chilean and Peruvian models
MX : Mexiccan model
Ref. No.
• Items marked “*” are not stocked since they
are seldom required for routine service.
Some delay should be anticipated when ordering these items.
• SEMICONDUCTORS
In each case, u: µ, for example:
uA. . : µA. .
uPA. . : µPA. .
uPB. . : µPB. .
uPC. . : µPC. .
uPD. . : µPD. .
• CAPACITORS
uF: µF
• COILS
uH: µH
Part No.
Description
Remark
A-4733-391-A
A-4733-418-A
A-4733-430-A
A-4733-432-A
ACDC BOARD, COMPLETE (US)
ACDC BOARD, COMPLETE (E51)
ACDC BOARD, COMPLETE (MX)
ACDC BOARD, COMPLETE (AEP. UK)
*********************
Ref. No.
Part No.
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
When indicating parts by reference
number, please include the board.
Description
Remark
< TERMINAL >
CLP007 1-537-933-31 TERMINAL
< CONNECTOR >
* CN003
CN006
CN011
1-533-213-31 FUSE HOLDER (MX)
1-533-217-31 FUSE HOLDER (US, E51)
*
ACDC
1-564-516-11 PLUG, CONNECTOR 13P
1-564-507-11 PLUG, CONNECTOR 4P
1-564-321-00 PIN, CONNECTOR (3.96mm PITCH) 2P
< CAPACITOR >
< DIODE >
C001
1-130-777-00 MYLAR
0.1uF
C002
1-130-777-00 MYLAR
0.1uF
C003
C004
C007
1-130-777-00 MYLAR
1-130-777-00 MYLAR
1-130-777-00 MYLAR
0.1uF
0.1uF
0.1uF
C008
C010
1-130-777-00 MYLAR
1-126-943-11 ELECT
0.1uF
2200uF
C011
1-119-940-51 ELECT
4700uF
C011
1-126-955-11 ELECT
4700uF
C012
1-119-940-51 ELECT
4700uF
C012
1-126-955-11 ELECT
4700uF
C015
1-127-814-11 ELECT
3300uF
C015
1-135-516-11 ELECT
3300uF
C015
1-135-517-11 ELECT
3300uF
C016
1-127-814-11 ELECT
3300uF
5%
100V
(US, E51, MX)
5%
100V
(US, E51, MX)
5%
100V
5%
100V
5%
100V
5%
100V
20%
25V
(US, E51, MX)
20%
50V
(E51, MX)
20%
35V
(US, AEP, UK)
20%
50V
(E51, MX)
20%
35V
(US, AEP, UK)
20%
80V
(E51, MX)
20%
63V
(AEP, UK)
20%
71V
(US)
20%
80V
(E51, MX)
C016
1-135-516-11 ELECT
3300uF
20%
C016
1-135-517-11 ELECT
3300uF
20%
C029
C120
C121
1-126-941-11 ELECT
1-162-968-11 CERAMIC CHIP
1-126-964-11 ELECT
470uF
20%
0.0047uF 10%
10uF
20%
C122
C123
C124
1-126-963-11 ELECT
1-126-957-11 ELECT
1-126-947-11 ELECT
4.7uF
0.22uF
47uF
20%
20%
20%
63V
(AEP, UK)
71V
(US)
25V
50V
50V
D002
D002
D004
D004
D005
8-719-500-56
8-719-510-68
8-719-510-68
6-500-360-01
8-719-801-78
DIODE
DIODE
DIODE
DIODE
DIODE
D3SBA20 (US, AEP, UK)
D5SBA204101 (E51, MX)
D5SBA204101 (US, AEP, UK)
D10XB20 (E51, MX)
1SS184-TE85L
D006
D007
D008
D009
D010
8-719-820-05
8-719-048-61
8-719-048-61
8-719-048-61
8-719-048-61
DIODE
DIODE
DIODE
DIODE
DIODE
1SS181-TE85L
EGP20DL-6349 (US, E51, MX)
EGP20DL-6349 (US, E51, MX)
EGP20DL-6349 (US, E51, MX)
EGP20DL-6349 (US, E51, MX)
D023
D111
D112
D113
D114
8-719-988-61
8-719-988-61
8-719-820-05
8-719-801-78
8-719-801-78
DIODE
DIODE
DIODE
DIODE
DIODE
1SS355TE-17
1SS355TE-17
1SS181-TE85L
1SS184-TE85L
1SS184-TE85L
D115
D116
D117
D118
D139
8-719-820-05
8-719-801-78
8-719-820-05
8-719-988-61
8-719-801-78
DIODE
DIODE
DIODE
DIODE
DIODE
1SS181-TE85L
1SS184-TE85L
1SS181-TE85L
1SS355TE-17
1SS184-TE85L
D140
8-719-820-05 DIODE 1SS181-TE85L
< GROUND TERMINAL >
* EP001
1-537-738-21 TERMINAL, EARTH
< TRANSFORMER >
0 PT005
0 PT006
0 PT006
0 PT006
50V
50V
25V
1-439-736-11
1-439-734-11
1-439-944-11
1-439-735-11
TRANSFORMER, POWER (E51)
TRANSFORMER, POWER (US)
TRANSFORMER, POWER (MX)
TRANSFORMER, POWER (AEP. UK)
< TRANSISTOR >
Q101
8-729-120-28 TRANSISTOR
2SC3052F-T1-LF
93
CX-BK1
ACDC
Ref. No.
AMP
Part No.
Description
Q102
Q103
Q104
Q105
8-729-120-28
8-729-120-28
6-550-580-01
6-550-580-01
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC3052F-T1-LF
2SC3052F-T1-LF
2SA1235TP-1F
2SA1235TP-1F
Remark
Q106
Q107
Q108
Q109
8-729-120-28
8-729-120-28
8-729-120-28
8-729-120-28
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC3052F-T1-LF
2SC3052F-T1-LF
2SC3052F-T1-LF
2SC3052F-T1-LF
Ref. No.
Part No.
Description
1-216-827-11 METAL CHIP
3.3K
5%
R157
1-216-828-11 METAL CHIP
3.9K
5%
0 RY001
0 RY502
1-755-276-11 RELAY, POWER (EXCEPT E51)
1-755-496-11 RELAY (E51)
< SWITCH >
1-202-723-00 SOLID
2.2M
20%
R101
R102
R103
R104
1-216-829-11
1-216-833-11
1-216-809-11
1-216-829-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
10K
100
4.7K
5%
5%
5%
5%
1/2W F
(US)
1/10W
1/10W
1/10W
1/10W
R105
R106
R107
R108
R109
1-216-833-11
1-216-842-11
1-216-842-11
1-216-842-11
1-216-842-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
56K
56K
56K
56K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R110
R111
R112
R113
R114
1-216-821-11
1-216-821-11
1-218-867-11
1-216-206-00
1-218-867-11
METAL CHIP
METAL CHIP
METAL CHIP
RES-CHIP
METAL CHIP
1K
1K
6.8K
2.2K
6.8K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/8W
1/10W
R115
R116
R117
R118
R119
1-216-834-11
1-216-821-11
1-216-821-11
1-216-809-11
1-216-835-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
12K
1K
1K
100
15K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R120
R121
R122
R123
R128
1-216-833-11
1-216-835-11
1-216-839-11
1-216-839-11
1-216-198-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
RES-CHIP
10K
15K
33K
33K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/8W
R130
R131
R132
1-216-836-11 METAL CHIP
1-216-836-11 METAL CHIP
1-216-840-11 METAL CHIP
18K
18K
39K
5%
5%
5%
R132
1-216-841-11 METAL CHIP
47K
R133
1-216-833-11 METAL CHIP
10K
1/10W
1/10W
1/10W
(EXCEPT US)
5%
1/10W
(US)
5%
1/10W
R134
R135
1-216-844-11 METAL CHIP
1-216-840-11 METAL CHIP
82K
39K
5%
5%
R135
1-216-841-11 METAL CHIP
47K
R136
R137
1-216-833-11 METAL CHIP
1-216-844-11 METAL CHIP
10K
82K
1/10W
1/10W
(EXCEPT US)
5%
1/10W
(US)
5%
1/10W
5%
1/10W
R138
R139
R140
R147
R148
1-216-833-11
1-216-845-11
1-216-833-11
1-216-236-11
1-216-236-11
METAL CHIP
METAL CHIP
METAL CHIP
RES-CHIP
RES-CHIP
10K
100K
10K
39K
39K
5%
5%
5%
5%
5%
R156
R157
1-216-830-11 METAL CHIP
1-216-826-11 METAL CHIP
5.6K
2.7K
5%
5%
94
1/10W
(US)
1/10W
(AEP, UK)
< RELAY >
< RESISTOR >
0 R001
Remark
R157
0 S001
1-786-408-11 SW, SL 1-2-3 SWS2301 (VOLTAGE SELECTOR)
(E51)
**************************************************************
A-4733-393-A AMP BOARD, COMPLETE (US)
A-4733-415-A AMP BOARD, COMPLETE (E51, MX)
A-4733-434-A AMP BOARD, COMPLETE (AEP. UK)
*********************
< CAPACITOR >
C001
C002
C003
C004
C005
1-164-156-11
1-164-156-11
1-126-947-11
1-126-965-11
1-126-965-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
ELECT
0.1uF
0.1uF
47uF
22uF
22uF
20%
20%
20%
25V
25V
25V
50V
50V
C007
C008
C009
C025
C026
1-164-156-11
1-164-156-11
1-126-947-11
1-162-969-11
1-162-968-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
47uF
20%
0.0068uF 10%
0.0047uF 10%
25V
25V
25V
25V
50V
C301
C302
C303
C501
C502
1-126-960-11
1-126-947-11
1-126-947-11
1-162-970-11
1-162-970-11
ELECT
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
1uF
47uF
47uF
0.01uF
0.01uF
20%
20%
20%
10%
10%
50V
25V
25V
25V
25V
C505
C506
C507
C508
C509
1-164-162-11
1-164-162-11
1-164-162-11
1-164-162-11
1-164-733-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100PF
100PF
100PF
100PF
820PF
5%
5%
5%
5%
10%
100V
100V
100V
100V
50V
C510
C511
C512
C513
C514
1-164-733-11
1-126-966-11
1-126-966-11
1-126-965-11
1-126-965-11
CERAMIC CHIP
ELECT
ELECT
ELECT
ELECT
820PF
33uF
33uF
22uF
22uF
10%
20%
20%
20%
20%
50V
50V
50V
50V
50V
C517
C518
C519
C520
C521
1-126-959-11
1-126-959-11
1-115-414-11
1-115-414-11
1-126-963-11
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT
0.47uF
0.47uF
820PF
820PF
4.7uF
20%
20%
5%
5%
20%
50V
50V
25V
25V
50V
1/10W
1/10W
1/10W
1/8W
1/8W
C522
C523
C524
C528
C536
1-126-963-11
1-164-156-11
1-164-156-11
1-164-156-11
1-126-956-91
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
4.7uF
0.1uF
0.1uF
0.1uF
0.1uF
20%
50V
25V
25V
25V
50V
1/10W
1/10W
(E51, MX)
C537
C575
C630
C631
1-126-956-91
1-164-156-11
1-162-961-11
1-162-961-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
330PF
330PF
20%
20%
10%
10%
50V
25V
50V
50V
The components identified by mark 0 or dotted
line with mark 0 are critical for safety.
Replace only with part number specified.
CX-BK1
AMP
Ref. No.
Part No.
Description
Remark
Ref. No.
Part No.
Description
Remark
< SHORT >
C633
1-126-947-11 ELECT
47uF
20%
35V
C634
C635
C636
C637
C638
1-128-552-51
1-163-833-00
1-162-927-11
1-128-552-51
1-162-959-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
47uF
0.068uF
100PF
47uF
330PF
20%
5%
20%
5%
63V
25V
50V
63V
50V
JR511
JR512
JR513
JR514
JR515
1-216-296-00
1-216-296-00
1-216-864-11
1-216-864-11
1-216-864-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
C640
C641
C642
C643
C645
1-162-961-11
1-126-947-11
1-162-945-11
1-162-959-11
1-162-961-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
330PF
47uF
22PF
330PF
330PF
10%
20%
5%
5%
10%
50V
35V
50V
50V
50V
JR517
JR1113
JR1114
JR1115
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0 (US)
0 (E51)
0 (MX)
JR1116 1-216-864-11 SHORT CHIP
JR1117 1-216-864-11 SHORT CHIP
JR1130 1-216-864-11 SHORT CHIP
0 (UK)
0 (AEP)
0 (AEP)
< CONNECTOR >
* CN303
CN502
1-564-518-11 PLUG, CONNECTOR 3P
1-568-830-11 CONNECTOR, FFC 11P
< DIODE >
D002
D020
D301
D501
D502
8-719-988-61
8-719-801-78
8-719-801-78
8-719-820-05
8-719-820-05
DIODE
DIODE
DIODE
DIODE
DIODE
1SS355TE-17
1SS184-TE85L
1SS184-TE85L
1SS181-TE85L
1SS181-TE85L
D503
D504
D505
D506
D507
8-719-801-78
8-719-801-78
8-719-046-74
8-719-046-74
8-719-988-61
DIODE
DIODE
DIODE
DIODE
DIODE
1SS184-TE85L
1SS184-TE85L
AU-01Z-WS
AU-01Z-WS
1SS355TE-17
D508
D509
D510
D511
D618
8-719-988-61
8-719-801-78
8-719-820-05
8-719-988-61
8-719-801-78
DIODE
DIODE
DIODE
DIODE
DIODE
1SS355TE-17
1SS184-TE85L
1SS181-TE85L
1SS355TE-17
1SS184-TE85L
D619
D623
D624
D625
D626
8-719-820-05
8-719-988-61
8-719-988-61
8-719-060-80
8-719-312-08
DIODE
DIODE
DIODE
DIODE
DIODE
1SS181-TE85L
1SS355TE-17
1SS355TE-17
MA8180-L-TX
FMB-G16L
D627
D629
D630
D631
D632
8-719-312-08
8-719-988-61
8-719-083-83
8-719-988-61
8-719-988-61
DIODE
DIODE
DIODE
DIODE
DIODE
FMB-G16L
1SS355TE-17
UDZS-TE17-15B
1SS355TE-17
1SS355TE-17
D633
D634
D635
D636
D637
8-719-988-61
8-719-988-61
8-719-988-61
8-719-988-61
8-719-988-61
DIODE
DIODE
DIODE
DIODE
DIODE
1SS355TE-17
1SS355TE-17
1SS355TE-17
1SS355TE-17
1SS355TE-17
D638
8-719-988-61 DIODE 1SS355TE-17
< GROUND TERMINAL >
* EP501
* EP502
1-537-738-21 TERMINAL, EARTH
1-537-738-21 TERMINAL, EARTH
< TRANSISTOR >
Q012
Q013
Q301
Q302
Q303
8-729-271-31
8-729-216-31
8-729-120-28
6-550-580-01
8-729-201-53
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC2713G-TE85L
2SA1163G-TE85L
2SC3052F-T1-LF
2SA1235TP-1F
2SA1015TP-GR
Q505
Q506
Q507
Q508
Q509
8-729-216-31
8-729-216-31
8-729-120-28
8-729-120-28
8-729-120-28
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SA1163G-TE85L
2SA1163G-TE85L
2SC3052F-T1-LF
2SC3052F-T1-LF
2SC3052F-T1-LF
Q510
Q511
Q512
Q513
Q514
8-729-120-28
8-729-823-91
8-729-823-91
8-729-823-91
8-729-823-91
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC3052F-T1-LF
2SC2910ST-TP
2SC2910ST-TP
2SC2910ST-TP
2SC2910ST-TP
Q515
Q516
Q517
Q518
Q521
8-729-271-31
8-729-271-31
6-550-032-01
6-550-032-01
8-729-120-28
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC2713G-TE85L
2SC2713G-TE85L
HN4A06J-GRBL (TE85R)
HN4A06J-GRBL (TE85R)
2SC3052F-T1-LF
Q522
Q523
Q524
Q525
Q526
8-729-120-28
8-729-120-28
8-729-120-28
8-729-052-79
8-729-052-79
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC3052F-T1-LF
2SC3052F-T1-LF
2SC3052F-T1-LF
2SD1306NETL
2SD1306NETL
Q527
Q530
Q610
Q611
Q617
6-550-580-01
8-729-120-28
8-729-216-31
8-729-027-23
6-550-580-01
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SA1235TP-1F
2SC3052F-T1-LF
2SA1163G-TE85L
DTA114EKA-T146
2SA1235TP-1F
Q618
Q619
Q620
Q621
Q622
6-550-040-01
6-550-040-01
6-550-317-01
8-729-120-28
6-550-316-01
FET
FET
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SK3053
2SK3053
2SD814A (RS)
2SC3052F-T1-LF
2SB792A (RS)
Q623
Q624
6-550-580-01 TRANSISTOR
6-550-580-01 TRANSISTOR
< RESISTOR >
< IC >
IC001
IC003
8-759-071-48 IC TA7807S
8-759-231-58 IC TA7812S
2SA1235TP-1F
2SA1235TP-1F
R035
R036
R037
1-216-837-11 METAL CHIP
1-216-837-11 METAL CHIP
1-216-830-11 METAL CHIP
22K
22K
5.6K
5%
5%
5%
1/10W
1/10W
1/10W
95
CX-BK1
AMP
Ref. No.
Part No.
Description
Remark
R065
R066
1-216-073-00 RES-CHIP
1-216-085-00 RES-CHIP
10K
33K
5%
5%
1/10W
1/10W
R067
R068
R090
R301
R302
1-216-089-11
1-216-833-11
1-216-073-00
1-216-841-11
1-216-853-11
RES-CHIP
METAL CHIP
RES-CHIP
METAL CHIP
METAL CHIP
47K
10K
10K
47K
470K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R303
R304
R305
R306
R307
1-216-827-11
1-216-813-11
1-216-833-11
1-216-833-11
1-216-792-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
3.3K
220
10K
10K
3.9
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R311
R312
0 R501
1-216-829-11 METAL CHIP
1-216-829-11 METAL CHIP
1-220-890-11 METAL
4.7K
4.7K
0.22
0 R502
1-220-890-11 METAL
0.22
0 R503
1-220-890-11 METAL
0.22
5%
1/10W
5%
1/10W
10%
3W
F
(US, E51, MX)
10%
3W
F
(US, E51, MX)
10%
3W
F
(US, E51, MX)
0 R504
1-220-890-11 METAL
0.22
R505
R506
R507
1-216-809-11 METAL CHIP
1-216-809-11 METAL CHIP
1-216-822-11 METAL CHIP
100
100
1.2K
R507
1-216-823-11 METAL CHIP
1.5K
10%
3W
F
(US, E51, MX)
5%
1/10W
5%
1/10W
5%
1/10W
(US, E51, MX)
5%
1/10W
(AEP, UK)
R508
1-216-822-11 METAL CHIP
1.2K
R508
1-216-823-11 METAL CHIP
1.5K
R509
R510
R511
1-216-826-11 METAL CHIP
1-216-826-11 METAL CHIP
1-216-821-11 METAL CHIP
2.7K
2.7K
1K
5%
1/10W
(US, E51, MX)
5%
1/10W
(AEP, UK)
5%
1/10W
5%
1/10W
5%
1/10W
R512
R513
R514
R515
R516
1-216-821-11
1-218-867-11
1-218-867-11
1-216-033-00
1-216-033-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
6.8K
6.8K
220
220
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R517
R518
R519
R520
R521
1-216-015-00
1-216-015-00
1-216-015-00
1-216-015-00
1-216-824-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
39
39
39
39
1.8K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R522
R523
R524
R525
R526
1-216-824-11
1-216-825-11
1-216-825-11
1-216-821-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1.8K
2.2K
2.2K
1K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R527
R528
R529
R530
R531
1-216-841-11
1-216-841-11
1-216-829-11
1-216-829-11
1-216-823-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
47K
4.7K
4.7K
1.5K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R532
R533
R534
R535
1-216-823-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1.5K
100
100
100
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
96
Ref. No.
Part No.
Description
Remark
R536
1-216-809-11 METAL CHIP
100
5%
R537
1-247-713-11 CARBON
1K
5%
R537
1-249-923-11 CARBON
1K
R538
1-247-713-11 CARBON
1K
R538
1-249-923-11 CARBON
1K
R539
1-216-833-11 METAL CHIP
10K
1/2W
(E51, MX)
5%
1/4W
(US, AEP, UK)
5%
1/4W
(E51, MX)
5%
1/4W
(US, AEP, UK)
5%
1/10W
R540
R541
R542
R543
R544
1-216-833-11
1-216-206-00
1-216-206-00
1-216-206-00
1-216-206-00
METAL CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
10K
2.2K
2.2K
2.2K
2.2K
5%
5%
5%
5%
5%
1/10W
1/8W
1/8W
1/8W
1/8W
R545
R546
R547
R548
R549
1-216-809-11
1-216-809-11
1-216-083-00
1-216-083-00
1-216-039-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
RES-CHIP
100
100
27K
27K
390
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
(E51, MX)
R549
1-216-041-00 METAL CHIP
470
5%
R549
1-216-043-00 RES-CHIP
560
5%
R550
1-216-039-00 RES-CHIP
390
5%
R550
1-216-041-00 METAL CHIP
470
5%
R550
1-216-043-00 RES-CHIP
560
5%
1/10W
(US)
1/10W
(AEP, UK)
1/10W
(E51, MX)
1/10W
(US)
1/10W
(AEP, UK)
R553
R554
R555
R556
R557
1-216-838-11
1-216-838-11
1-216-845-11
1-216-845-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
27K
27K
100K
100K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R558
R559
R560
R561
R562
1-216-821-11
1-216-063-00
1-216-063-00
1-216-843-11
1-216-857-11
METAL CHIP
RES-CHIP
RES-CHIP
METAL CHIP
METAL CHIP
1K
3.9K
3.9K
68K
1M
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R564
R574
R575
R576
R591
1-216-864-11
1-216-009-00
1-216-833-11
1-216-833-11
1-216-845-11
SHORT CHIP
RES-CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
22
10K
10K
100K
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
2W
F
(AEP, UK)
2W
F
(E51, MX)
2W
F
(AEP, UK)
2W
F
(E51, MX)
R592
0 R595
1-216-835-11 METAL CHIP
1-220-755-11 METAL
15K
0.22
5%
10%
0 R595
1-217-153-00 METAL
0.47
10%
0 R596
1-220-755-11 METAL
0.22
10%
0 R596
1-217-153-00 METAL
0.47
10%
0 R597
1-220-755-11 METAL
0.22
10%
0 R597
1-217-153-00 METAL
0.47
10%
1/10W
2W
F
(AEP, UK)
2W
F
(E51, MX)
The components identified by mark 0 or dotted
line with mark 0 are critical for safety.
Replace only with part number specified.
CX-BK1
AMP
Ref. No.
Part No.
0 R598
1-220-755-11 METAL
Description
0.22
10%
Remark
0 R598
1-217-153-00 METAL
0.47
10%
R626
1-216-061-00 RES-CHIP
3.3K
5%
R627
R641
R642
1-216-833-11 METAL CHIP
1-216-081-00 METAL CHIP
1-216-055-00 METAL CHIP
10K
22K
1.8K
5%
5%
5%
R642
1-216-057-00 METAL CHIP
2.2K
R643
1-216-055-00 METAL CHIP
1.8K
2W
F
(AEP, UK)
2W
F
(E51, MX)
1/10W
1/10W
1/10W
1/10W
(E51, MX)
5%
1/10W
(US, AEP, UK)
5%
1/10W
(E51, MX)
Part No.
Description
Remark
R698
1-216-053-00 METAL CHIP
1.5K
R698
1-216-055-00 METAL CHIP
1.8K
R699
1-249-423-11 CARBON
3.3K
5%
1/10W
(E51, MX)
5%
1/10W
(US, AEP, UK)
5%
1/4W
< RELAY >
RY501
1-755-307-11 RELAY
< THERMISTOR >
TH501 1-803-790-21 THERMISTOR
TH502 1-803-790-21 THERMISTOR
**************************************************************
R643
1-216-057-00 METAL CHIP
2.2K
R645
R646
R647
R648
1-216-841-11
1-216-841-11
1-216-837-11
1-216-849-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
47K
22K
220K
1/10W
(US, AEP, UK)
5%
1/10W
5%
1/10W
5%
1/10W
5%
1/10W
R649
R650
R651
R652
R653
1-216-849-11
1-216-833-11
1-216-825-11
1-216-841-11
1-216-061-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
RES-CHIP
220K
10K
2.2K
47K
3.3K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
C101
C102
C103
C104
C107
1-164-315-11
1-107-826-11
1-164-315-11
1-162-967-11
1-162-921-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
470PF
0.1uF
470PF
0.0033uF
33PF
R654
R655
R656
R658
R659
1-216-835-11
1-249-419-11
1-249-420-11
1-216-186-00
1-216-184-00
METAL CHIP
CARBON
CARBON
RES-CHIP
RES-CHIP
15K
1.5K
1.8K
330
270
5%
5%
5%
5%
5%
1/10W
1/4W
1/4W
1/8W
1/8W
C108
C109
C110
C111
C112
1-164-360-11
1-164-360-11
1-107-826-11
1-126-607-11
1-164-360-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
47uF
0.1uF
R660
R661
R662
R663
R664
1-216-826-11
1-216-061-00
1-216-833-11
1-216-833-11
1-216-061-00
METAL CHIP
RES-CHIP
METAL CHIP
METAL CHIP
RES-CHIP
2.7K
3.3K
10K
10K
3.3K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
C113
C114
C115
C116
C117
1-128-995-21
1-162-964-11
1-128-995-21
1-107-826-11
1-164-360-11
ELECT CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
100uF
0.001uF
100uF
0.1uF
0.1uF
R669
R670
R671
R672
R674
1-216-833-11
1-216-835-11
1-216-833-11
1-216-829-11
1-216-238-91
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
RES-CHIP
10K
15K
10K
4.7K
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/8W
C118
C119
C121
C122
C131
1-115-156-11
1-115-156-11
1-216-864-11
1-164-360-11
1-110-563-11
CERAMIC CHIP
CERAMIC CHIP
SHORT CHIP
CERAMIC CHIP
CERAMIC CHIP
1uF
1uF
0
0.1uF
0.068uF
R675
R676
R677
R678
R679
1-216-825-11
1-216-826-11
1-216-061-00
1-216-234-00
1-216-830-11
METAL CHIP
METAL CHIP
RES-CHIP
RES-CHIP
METAL CHIP
2.2K
2.7K
3.3K
33K
5.6K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/8W
1/10W
C132
C133
C150
C151
C152
1-164-227-11
1-125-838-11
1-128-394-11
1-164-360-11
1-164-360-11
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
0.022uF
2.2uF
220uF
0.1uF
0.1uF
R681
R682
R683
R685
R686
1-259-583-11
1-216-835-11
1-216-214-00
1-216-825-11
1-249-423-11
CARBON
METAL CHIP
RES-CHIP
METAL CHIP
CARBON
15K
15K
4.7K
2.2K
3.3K
5%
5%
5%
5%
5%
1/2W
1/10W
1/8W
1/10W
1/4W
C153
C156
C169
C202
C203
1-164-360-11
1-162-970-11
1-128-394-11
1-164-360-11
1-162-964-11
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.01uF
220uF
0.1uF
0.001uF
10%
16V
25V
10V
16V
50V
R691
R692
R693
R694
R695
1-216-176-11
1-249-423-11
1-249-423-11
1-216-833-11
1-249-433-11
RES-CHIP
CARBON
CARBON
METAL CHIP
CARBON
120
3.3K
3.3K
10K
22K
5%
5%
5%
5%
5%
1/8W
1/4W
1/4W
1/10W
1/4W
C205
C208
C209
C211
C212
1-164-360-11
1-164-360-11
1-162-927-11
1-107-826-11
1-162-965-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
100PF
5%
0.1uF
10%
0.0015uF 10%
16V
16V
50V
16V
50V
R696
R697
1-216-226-00 RES-CHIP
1-216-053-00 METAL CHIP
15K
1.5K
5%
5%
R697
1-216-055-00 METAL CHIP
1.8K
C213
C215
C216
C222
C224
1-162-967-11
1-117-863-11
1-162-970-11
1-164-360-11
1-115-156-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.0033uF 10%
0.47uF
10%
0.01uF
10%
0.1uF
1uF
50V
6.3V
25V
16V
10V
The components identified by mark 0 or dotted
line with mark 0 are critical for safety.
Replace only with part number specified.
5%
Ref. No.
BD
1/8W
1/10W
(E51, MX)
5%
1/10W
(US, AEP, UK)
A-4731-674-A BD BOARD, COMPLETE
*******************
< CAPACITOR/SHORT >
5%
10%
5%
10%
5%
10%
20%
20%
10%
20%
10%
50V
16V
50V
50V
50V
16V
16V
16V
4V
16V
10V
50V
10V
16V
16V
10V
10V
10%
10%
10%
20%
10%
20%
16V
16V
25V
6.3V
10V
16V
16V
97
CX-BK1
BD
Ref. No.
Part No.
Description
Remark
Ref. No.
Part No.
Description
Remark
< SHORT >
C226
C227
C229
C230
C231
1-126-607-11
1-164-360-11
1-164-360-11
1-164-360-11
1-100-588-21
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
47uF
0.1uF
0.1uF
0.1uF
1000uF
20%
20%
4V
16V
16V
16V
6.3V
C249
C250
C251
C253
C254
1-164-360-11
1-164-360-11
1-164-360-11
1-164-360-11
1-162-919-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.1uF
22PF
5%
16V
16V
16V
16V
50V
C255
C256
C257
C258
C259
1-164-360-11
1-164-360-11
1-128-934-11
1-162-919-11
1-164-360-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.33uF
22PF
0.1uF
C260
C261
C263
C264
C265
1-128-590-11
1-126-246-11
1-126-607-11
1-126-607-11
1-126-607-11
ELECT CHIP
ELECT CHIP
ELECT CHIP
ELECT CHIP
ELECT CHIP
100uF
220uF
47uF
47uF
47uF
20%
20%
20%
20%
20%
6.3V
4V
4V
4V
4V
C266
C267
C268
C269
C270
1-164-360-11
1-162-968-11
1-162-968-11
1-126-607-11
1-162-960-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
0.1uF
0.0047uF
0.0047uF
47uF
220PF
10%
10%
20%
10%
16V
50V
50V
4V
50V
C271
C272
C273
C274
C292
1-162-970-11
1-216-864-11
1-162-960-11
1-162-970-11
1-164-360-11
CERAMIC CHIP
SHORT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0
220PF
0.01uF
0.1uF
10%
25V
10%
10%
50V
25V
16V
C310
C313
C314
C316
1-164-360-11
1-164-360-11
1-115-156-11
1-164-360-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
1uF
0.1uF
20%
5%
16V
16V
10V
50V
16V
L101
L163
1-412-032-11 INDUCTOR CHIP 100uH
1-216-864-11 SHORT CHIP
0
< TRANSISTOR >
Q101
8-729-046-90 TRANSISTOR
2SB970-(TX).S0
< RESISTOR/CAPACITOR >
0
15K
100K
15K
1K
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
R111
R113
R114
R115
R116
1-216-847-11
1-218-701-11
1-216-852-11
1-216-839-11
1-216-839-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
150K
2.4K
390K
33K
33K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R117
R118
R120
R122
R123
1-216-846-11
1-216-833-11
1-216-846-11
1-216-845-11
1-216-791-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
120K
10K
120K
100K
3.3
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R125
R126
R131
R132
R133
1-216-840-11
1-216-840-11
1-216-843-11
1-216-851-11
1-216-825-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
39K
39K
68K
330K
2.2K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R151
R152
R155
R162
R163
1-216-845-11
1-216-825-11
1-216-864-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
100K
2.2K
0
10K
10K
5%
5%
1/10W
1/10W
5%
5%
1/10W
1/10W
R166
R167
R168
R169
R199
1-216-821-11
1-216-864-11
1-216-821-11
1-216-864-11
1-216-864-11
METAL CHIP
SHORT CHIP
METAL CHIP
SHORT CHIP
SHORT CHIP
1K
0
1K
0
0
5%
1/10W
5%
1/10W
R201
R202
R203
R204
R205
1-216-839-11
1-216-833-11
1-216-845-11
1-216-827-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
33K
10K
100K
3.3K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
< IC >
R206
R207
R216
R218
R219
1-216-829-11
1-216-857-11
1-216-857-11
1-216-821-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
1M
1M
1K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
IC
IC
IC
IC
IC
R220
R221
R222
R223
R224
1-216-821-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
100
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
FB102
FB103
FB104
* FB161
FB201
1-216-864-11
1-216-864-11
1-216-864-11
1-469-670-21
1-216-295-00
SHORT CHIP
SHORT CHIP
SHORT CHIP
FERRITE
SHORT CHIP
0
0
0
0uH
0
FB203
FB204
FB291
FB351
1-216-864-11
1-216-295-00
1-216-864-11
1-216-864-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
98
< COIL >
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
16V
16V
10V
16V
1-794-424-11 CONNECTOR, FCC/FPC 16P
1-784-834-21 CONNECTOR, FFC (LIF (NON-ZIF)) 23P
1-784-863-21 CONNECTOR, FFC (LIF (NON-ZIF)) 11P
8-752-408-73
8-759-713-70
8-752-106-21
6-701-810-01
6-700-394-01
0
1-216-864-11
1-216-835-11
1-216-845-11
1-216-835-11
1-216-821-11
< SHORT/FERRITE BEAD >
IC101
IC102
IC103
IC104
IC121
1-216-864-11 SHORT CHIP
R101
R102
R103
R104
R105
< CONNECTOR >
CN101
CN102
CN104
JR1
CXD3068Q
AN41020A
CXA2647N-T4
TC94A20F-CX4
BA25BC0FP-E2
CX-BK1
BD
Ref. No.
Part No.
Description
R225
R226
R227
R230
R231
1-216-809-11
1-216-809-11
1-216-809-11
1-216-811-11
1-216-815-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
150
330
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
Remark
R232
R233
R249
R250
R251
1-216-815-11
1-216-815-11
1-216-818-11
1-216-813-11
1-216-813-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
330
330
560
220
220
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R252
R253
R255
R257
R259
1-216-857-11
1-216-821-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1M
1K
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R260
R261
R265
R266
R271
1-216-821-11
1-164-360-11
1-216-813-11
1-216-813-11
1-216-833-11
METAL CHIP
CERAMIC CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
0.1uF
220
220
10K
5%
5%
5%
5%
1/10W
16V
1/10W
1/10W
1/10W
R272
R275
R276
R279
R284
1-216-829-11
1-216-833-11
1-216-809-11
1-216-809-11
1-162-960-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
CERAMIC CHIP
4.7K
10K
100
100
220PF
5%
5%
5%
5%
10%
1/10W
1/10W
1/10W
1/10W
50V
R291
R303
R308
R309
R310
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
R311
R313
R314
R316
R318
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
R319
R321
R351
1-216-864-11 SHORT CHIP
1-216-864-11 SHORT CHIP
1-216-864-11 SHORT CHIP
0
0
0
Ref. No.
C763
C764
C765
C766
C767
1-164-159-21
1-164-159-21
1-164-159-21
1-164-159-21
1-164-159-21
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
50V
50V
50V
50V
50V
C768
C769
C771
C781
1-164-159-21
1-164-159-21
1-162-306-11
1-162-306-11
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.1uF
0.1uF
0.01uF
0.01uF
50V
50V
16V
16V
CN701
CN702
CN703
* CN710
1-779-564-21
1-785-329-11
1-785-328-11
1-506-486-11
D701
D711
D721
8-719-921-40 DIODE MTZJ-T-77-4.7B
8-719-109-89 DIODE MTZJ-T-77-5.6B
8-719-982-03 DIODE MTZJ-T-77-3.6A
< IC >
R701
R702
R711
R712
R721
8-759-598-69 IC BA6956AN
8-759-598-69 IC BA6956AN
8-759-598-69 IC BA6956AN
8-729-029-66 TRANSISTOR
0.1uF
0.1uF
0.1uF
RT1N141S-TP
1-249-415-11
1-247-807-31
1-249-415-11
1-247-807-31
1-249-415-11
CARBON
CARBON
CARBON
CARBON
CARBON
680
100
680
100
680
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R722
1-247-807-31 CARBON
100
5%
1/4W
R731
1-247-806-11 CARBON
91
5%
1/4W
R732
1-249-417-11 CARBON
1K
5%
1/4W
R733
1-249-429-11 CARBON
10K
5%
1/4W
R734
1-249-429-11 CARBON
10K
5%
1/4W
**************************************************************
A-4733-420-A DECK BOARD, COMPLETE (EXCEPT US)
*********************
< CAPACITOR >
< CAPACITOR >
1-164-159-21 CERAMIC
1-164-159-21 CERAMIC
1-164-159-21 CERAMIC
CONNECTOR, FFC (LIF (NON-ZIF)) 27P
PIN, CONNECTOR (LIGHT ANGLE) 3P
PIN, CONNECTOR (LIGHT ANGRE) 2P
PIN, CONNECTOR 7P
< DIODE >
A-4731-113-A CONNECTOR BOARD, COMPLETE
***************************
C755
C756
C758
30%
30%
16V
50V
< CONNECTOR >
X201
1-767-408-21 VIBRATOR, CRYSTAL (16.9344MHz)
**************************************************************
10uF
0.1uF
0.1uF
0.1uF
0.1uF
30%
< RESISTOR >
< VIBRATOR >
ELECT
CERAMIC
CERAMIC
CERAMIC
CERAMIC
Remark
0.01uF
0.1uF
< TRANSISTOR >
1-223-997-21 RES, CARBON ADJ VAR 47K
1-126-795-11
1-164-159-21
1-164-159-21
1-164-159-21
1-164-159-21
Description
1-162-306-11 CERAMIC
1-164-159-21 CERAMIC
IC701
IC711
IC721
< VARIABLE RESISTOR >
C711
C751
C752
C753
C754
DECK
C761
C762
Q731
RV101
Part No.
CONNECTOR
20%
50V
50V
50V
50V
50V
50V
50V
50V
C303
C304
C307
C308
C309
1-164-647-11
1-164-647-11
1-104-665-11
1-104-665-11
1-162-923-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP
0.0012uF
0.0012uF
100uF
100uF
47PF
10%
10%
20%
20%
5%
50V
50V
10V
10V
50V
C310
C313
C314
C315
C317
1-162-923-11
1-163-019-00
1-163-019-00
1-126-964-11
1-126-956-91
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
47PF
0.0068uF
0.0068uF
220uF
0.1uF
5%
10%
10%
20%
20%
50V
50V
50V
16V
50V
99
CX-BK1
DECK
Ref. No.
Part No.
Description
C318
C325
C326
C327
C360
1-126-956-91
1-164-156-11
1-164-227-11
1-107-826-11
1-126-964-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
0.1uF
0.1uF
0.022uF
0.1uF
220uF
10%
10%
20%
50V
25V
25V
16V
16V
Remark
C399
C401
C402
C403
C404
1-164-315-11
1-126-956-91
1-126-956-91
1-162-926-11
1-162-926-11
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
470PF
0.1uF
0.1uF
82PF
82PF
5%
20%
20%
5%
5%
50V
50V
50V
50V
50V
C405
C406
C407
C408
C409
1-162-970-11
1-162-970-11
1-162-970-11
1-162-970-11
1-162-968-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.01uF
0.01uF
0.01uF
0.0047uF
10%
10%
10%
10%
10%
25V
25V
25V
25V
50V
C410
C411
C412
C413
C452
1-162-968-11
1-126-964-11
1-126-964-11
1-164-156-11
1-128-551-11
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP
ELECT
0.0047uF
10uF
10uF
0.1uF
22uF
10%
20%
20%
20%
50V
50V
50V
25V
25V
C453
C454
C455
C456
C457
1-164-650-91
1-164-650-91
1-164-650-91
1-162-970-11
1-137-459-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
MYLAR
0.0027uF
0.0027uF
0.0027uF
0.01uF
0.0056uF
10%
10%
10%
10%
5%
50V
50V
50V
25V
100V
C458
C459
C460
C461
C462
1-162-964-11
1-164-739-11
1-107-826-11
1-164-392-11
1-164-392-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.001uF
560PF
0.1uF
390PF
390PF
10%
5%
10%
5%
5%
50V
50V
16V
50V
50V
20%
Ref. No.
JR401
JR402
Part No.
Description
1-216-295-00 SHORT CHIP
1-216-296-00 SHORT CHIP
Remark
0
0
< COIL >
L451
1-456-094-11 COIL, OSC
85KHZ BIAS
< TRANSISTOR >
Q305
Q306
Q307
Q308
Q309
6-550-290-01
8-729-034-49
6-550-290-01
6-550-290-01
8-729-230-69
FET
TRANSISTOR
FET
FET
TRANSISTOR
2SJ460
KRC104S
2SJ460
2SJ460
2SA1362G
Q310
Q443
Q444
Q451
Q453
8-729-230-69
8-729-230-69
8-729-230-69
6-550-297-01
8-729-036-89
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SA1362G
2SA1362G
2SA1362G
2SA1981Y
KTC3198GR-A
Q454
8-729-036-89 TRANSISTOR
KTC3198GR-A
< RESISTOR >
R303
R304
R305
R306
R307
1-216-844-11
1-216-844-11
1-216-849-11
1-216-828-11
1-216-817-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
82K
82K
220K
3.9K
470
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R308
R309
R310
R313
R314
1-216-817-11
1-216-806-11
1-216-806-11
1-216-836-11
1-216-836-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
470
56
56
18K
18K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R315
R316
R317
R318
R319
1-216-852-11
1-216-852-11
1-216-822-11
1-216-822-11
1-216-829-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
390K
390K
1.2K
1.2K
4.7K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R321
R322
R323
R375
R376
1-216-864-11
1-216-864-11
1-216-174-11
1-216-822-11
1-216-821-11
SHORT CHIP
SHORT CHIP
RES-CHIP
METAL CHIP
METAL CHIP
0
0
100
1.2K
1K
5%
5%
5%
1/8W
1/10W
1/10W
R399
R401
R402
R403
R404
1-216-857-11
1-216-846-11
1-216-846-11
1-216-821-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1M
120K
120K
1K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R405
R406
R407
R408
R409
1-216-841-11
1-216-841-11
1-216-821-11
1-216-821-11
1-216-822-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
47K
1K
1K
1.2K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R410
R411
R412
R413
R414
1-216-822-11
1-216-835-11
1-216-835-11
1-216-825-11
1-216-825-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1.2K
15K
15K
2.2K
2.2K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R415
R416
1-216-819-11 METAL CHIP
1-216-819-11 METAL CHIP
680
680
5%
5%
1/10W
1/10W
< CONNECTOR >
CN008
* CN302
1-568-830-11 CONNECTOR, FFC 11P
1-564-710-11 PIN, CONNECTOR (SMALL TYPE) 8P
< DIODE >
D401
8-719-988-61 DIODE 1SS355TE-17
< GROUND TERMINAL >
* EP301
1-537-738-21 TERMINAL, EARTH
< SHORT >
FB301
1-216-864-11 SHORT CHIP
0
< IC >
IC301
IC401
6-702-457-01 IC NJM14558M-TE2
6-702-457-01 IC NJM14558M-TE2
< SHORT >
JR302
JR303
JR304
JR318
JR319
1-216-295-00
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
JR320
JR321
JR322
1-216-864-11 SHORT CHIP
1-216-296-00 SHORT CHIP
1-216-864-11 SHORT CHIP
0
0
0
100
CX-BK1
DECK
Ref. No.
Part No.
Description
Remark
R417
R418
R419
1-216-833-11 METAL CHIP
1-216-833-11 METAL CHIP
1-216-821-11 METAL CHIP
10K
10K
1K
5%
5%
5%
1/10W
1/10W
1/10W
R420
R421
R422
R423
R424
1-216-821-11
1-216-837-11
1-216-837-11
1-216-836-11
1-216-836-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
22K
22K
18K
18K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R425
R453
R454
R455
R456
1-216-833-11
1-216-663-91
1-216-148-00
1-216-836-11
1-216-836-11
METAL CHIP
METAL CHIP
RES-CHIP
METAL CHIP
METAL CHIP
10K
3.3K
8.2
18K
18K
5%
5%
5%
5%
1/10W
1/10W
1/8W
1/10W
1/10W
R457
R458
R459
R460
R465
1-249-395-11
1-216-845-11
1-216-154-00
1-249-399-11
1-216-845-11
CARBON
METAL CHIP
RES-CHIP
CARBON
METAL CHIP
15
100K
15
33
100K
5%
5%
5%
5%
5%
1/4W
1/10W
1/8W
1/4W
1/10W
R466
1-216-845-11 METAL CHIP
100K
5%
1/10W
< VARIABLE RESISTOR >
SFR451 1-241-766-11 RES, ADJ, CARBON 33K
SFR452 1-241-766-11 RES, ADJ, CARBON 33K
**************************************************************
HEADPHONE
Ref. No.
Part No.
JOG
KEY LED RMC
Description
Remark
< RESISTOR >
R376
R377
R378
R379
R380
1-216-833-11
1-216-843-11
1-216-835-11
1-216-848-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
68K
15K
180K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
< SWITCH >
S304
1-478-133-11 ENCODER, ROTARY (MULTI JOG)
**************************************************************
A-4733-395-A KEY LED RMC BOARD, COMPLETE
****************************
< CAPACITOR >
C601
C602
C603
C604
C605
1-162-927-11
1-162-927-11
1-162-927-11
1-162-927-11
1-162-927-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100PF
100PF
100PF
100PF
100PF
5%
5%
5%
5%
5%
50V
50V
50V
50V
50V
C606
C607
C608
C609
C621
1-162-927-11
1-124-234-00
1-164-005-11
1-164-005-11
1-164-360-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100PF
22uF
0.47uF
0.47uF
0.1uF
5%
20%
50V
16V
25V
25V
16V
1-688-414-11 HEADPHONE BOARD
*****************
< CONNECTOR >
CN605
1-568-838-11 CONNECTOR, FFC 21P
< CAPACITOR >
< IC >
C550
1-115-467-11 CERAMIC CHIP
0.22
10%
10V
IC601
IC602
IC603
< CONNECTOR >
* CN530
8-759-396-78 IC BU2092F-E2
6-704-046-01 IC BU2099FV
6-600-217-01 IC RPM7238-H4
1-564-520-11 PLUG, CONNECTOR 5P
< SHORT >
< JACK >
J521
1-566-891-21 JACK (PHONES)
< SHORT >
JR501
1-216-296-00 SHORT CHIP
1-216-206-00
1-216-206-00
1-249-659-31
1-249-659-31
1-249-659-31
RES-CHIP
RES-CHIP
CARBON
CARBON
CARBON
1-216-864-11
1-216-864-11
1-216-296-00
1-216-296-00
1-216-296-00
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
JR606
JR607
JR608
JR609
JR610
1-216-296-00
1-216-296-00
1-216-296-00
1-216-296-00
1-216-296-00
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
JR611
1-216-864-11 SHORT CHIP
0
0
< RESISTOR >
R521
R522
R523
R524
R525
JR601
JR602
JR603
JR604
JR605
2.2K
2.2K
270
270
270
5%
5%
5%
5%
5%
1/8W
1/8W
1/2W
1/2W
1/2W
< LED >
R526
1-249-659-31 CARBON
270
5%
1/2W
**************************************************************
1-688-413-11 JOG BOARD
**********
LED631
LED632
LED633
LED634
LED635
8-719-057-28
8-719-057-28
8-719-057-28
8-719-057-28
8-719-057-28
LED
LED
LED
LED
LED
SML78420C-TP15 (DISC INDICATOR 1)
SML78420C-TP15 (DISC INDICATOR 2)
SML78420C-TP15 (DISC INDICATOR 3)
SML78420C-TP15 (DISC INDICATOR 4)
SML78420C-TP15 (DISC INDICATOR 5)
< CAPACITOR >
< TRANSISTOR >
C370
C371
C372
1-162-964-11 CERAMIC CHIP
1-162-927-11 CERAMIC CHIP
1-162-927-11 CERAMIC CHIP
0.001uF
100PF
100PF
10%
5%
5%
50V
50V
50V
Q601
Q602
Q603
6-550-336-01 TRANSISTOR
6-550-336-01 TRANSISTOR
6-550-336-01 TRANSISTOR
FMA9AT148
FMA9AT148
FMA9AT148
101
CX-BK1
KEY LED RMC
Ref. No.
Q604
Q605
Part No.
LCD VOL
Description
6-550-336-01 TRANSISTOR
6-550-336-01 TRANSISTOR
Remark
FMA9AT148
FMA9AT148
Ref. No.
Part No.
Description
Remark
S334
1-771-410-21 SWITCH, TACTILE (TUNING DOWN . m)
**************************************************************
< RESISTOR >
A-4733-394-A LCD VOL BOARD, COMPLETE
************************
R310
R311
R312
R313
R314
1-216-835-11
1-216-816-11
1-216-819-11
1-216-821-11
1-216-823-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
15K
390
680
1K
1.5K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R315
R316
R317
R318
R319
1-216-823-11
1-216-206-00
1-216-827-11
1-216-829-11
1-218-867-11
METAL CHIP
RES-CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1.5K
2.2K
3.3K
4.7K
6.8K
5%
5%
5%
5%
5%
1/10W
1/8W
1/10W
1/10W
1/10W
R320
R330
R331
R332
R333
1-216-833-11
1-216-835-11
1-216-816-11
1-216-819-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
15K
390
680
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R334
R601
R602
R603
R604
1-216-823-11
1-216-833-11
1-216-833-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1.5K
10K
10K
10K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R605
R606
R607
R608
R611
1-216-833-11
1-216-833-11
1-216-842-11
1-216-805-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10K
56K
47
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R616
R617
R618
R619
R620
1-216-198-00
1-216-192-00
1-216-192-00
1-216-192-00
1-216-192-00
RES-CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
560
560
560
560
5%
5%
5%
5%
5%
1/8W
1/8W
1/8W
1/8W
1/8W
IC001
R621
R622
R623
R624
R625
1-216-192-00
1-216-192-00
1-216-192-00
1-216-192-00
1-216-192-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
560
560
560
560
560
5%
5%
5%
5%
5%
1/8W
1/8W
1/8W
1/8W
1/8W
JR101
JR102
JR103
JR104
JR105
1-216-296-00
1-216-296-00
1-216-296-00
1-216-296-00
1-216-296-00
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
R626
1-216-192-00 METAL CHIP
560
5%
1/8W
JR106
JR107
JR108
JR109
JR110
1-216-296-00
1-216-296-00
1-216-296-00
1-216-296-00
1-216-296-00
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
JR111
JR201
JR202
JR203
1-216-296-00
1-216-864-11
1-216-864-11
1-216-864-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
< SWITCH >
S311
S312
S313
S314
S315
1-771-410-21
1-771-410-21
1-771-410-21
1-771-410-21
1-771-410-21
SWITCH, TACTILE (DISC SELECT 1)
SWITCH, TACTILE (DISC SELECT 2)
SWITCH, TACTILE (DISC SELECT 3)
SWITCH, TACTILE (DISC SELECT 4)
SWITCH, TACTILE (DISC SELECT 5)
S316
S317
S318
S319
S319
1-771-410-21
1-771-410-21
1-771-410-21
1-771-410-21
1-771-410-21
SWITCH, TACTILE (EJECT Z)
SWITCH, TACTILE (PAUSE/SET X)
SWITCH, TACTILE (STOP/CLEAR x)
SWITCH, TACTILE (PLAY MODE) (US)
SWITCH, TACTILE (REC z) (EXCEPT US)
S320
S320
S331
S332
S333
1-771-410-21
1-771-410-21
1-771-410-21
1-771-410-21
1-771-410-21
SWITCH, TACTILE (PRESET B) (US)
SWITCH, TACTILE (PRESET Y) (EXCEPT US)
SWITCH, TACTILE (ALBUM/PLAY LIST v)
SWITCH, TACTILE (ALBUM/PLAY LIST V)
SWITCH, TACTILE (TUNING UP > M)
< CAPACITOR >
C102
C103
C104
C105
C107
1-128-111-11
1-164-360-11
1-164-360-11
1-162-963-11
1-162-927-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100uF
0.1uF
0.1uF
680PF
100PF
20%
C108
C109
C110
C111
C361
1-162-927-11
1-162-927-11
1-164-360-11
1-115-467-11
1-162-964-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100PF
100PF
0.1uF
0.22uF
0.001uF
5%
5%
10%
10%
50V
50V
16V
10V
50V
C362
C363
C364
C365
C366
1-162-927-11
1-162-927-11
1-162-964-11
1-162-927-11
1-162-927-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100PF
100PF
0.001uF
100PF
100PF
5%
5%
10%
5%
5%
50V
50V
50V
50V
50V
C367
C368
C369
1-162-964-11 CERAMIC CHIP
1-162-927-11 CERAMIC CHIP
1-162-927-11 CERAMIC CHIP
0.001uF
100PF
100PF
10%
5%
5%
50V
50V
50V
10%
5%
25V
16V
16V
50V
50V
< CONNECTOR >
CN001
CN004
1-784-780-11 CONNECTOR, FFC 19P
1-568-838-11 CONNECTOR, FFC 21P
< IC >
6-704-218-01 IC LC75874E
< SHORT >
< LIQUID CRYSTAL DISPLAY >
LCD001 1-805-322-11 DISPLAY PANEL, LIQUID CRYSTAL
< LED >
102
LED204
LED205
LED206
LED207
LED208
8-719-061-96
8-719-061-96
8-719-061-96
8-719-061-96
8-719-061-96
LED
LED
LED
LED
LED
SLR-325DCT31 (ILLUMINATION)
SLR-325DCT31 (ILLUMINATION)
SLR-325DCT31 (ILLUMINATION)
SLR-325DCT31 (ILLUMINATION)
SLR-325DCT31 (ILLUMINATION)
CX-BK1
LCD VOL
Ref. No.
Part No.
Description
Remark
LED209
LED210
LED211
LED212
LED213
8-719-061-96
8-719-061-96
8-719-061-96
8-719-061-96
8-719-061-96
LED
LED
LED
LED
LED
SLR-325DCT31 (ILLUMINATION)
SLR-325DCT31 (ILLUMINATION)
SLR-325DCT31 (ILLUMINATION)
SLR-325DCT31 (ILLUMINATION)
SLR-325DCT31 (ILLUMINATION)
LED214
LED215
LED216
LED217
LED218
8-719-061-96
8-719-061-96
8-719-061-96
8-719-061-96
8-719-061-96
LED
LED
LED
LED
LED
SLR-325DCT31 (ILLUMINATION)
SLR-325DCT31 (ILLUMINATION)
SLR-325DCT31 (ILLUMINATION)
SLR-325DCT31 (ILLUMINATION)
SLR-325DCT31 (ILLUMINATION)
LED219
LED220
LED221
LED251
LED252
8-719-061-96
8-719-061-96
8-719-061-96
6-500-681-01
6-500-681-01
LED
LED
LED
LED
LED
SLR-325DCT31 (ILLUMINATION)
SLR-325DCT31 (ILLUMINATION)
SLR-325DCT31 (ILLUMINATION)
SELU1910CXMLF38 (LCD BACKLIGHT)
SELU1910CXMLF38 (LCD BACKLIGHT)
Ref. No.
LED
Part No.
LEFT BUTTON
MAIN
Description
Remark
LED BOARD
**********
< LED >
LED601 8-719-063-93 LED SLR325VC-N-T32
(DISC SLOT ILLUMINATION)
**************************************************************
1-688-407-11 LEFT BUTTON BOARD
******************
< LED >
LED253 6-500-681-01 LED SELU1910CXMLF38 (LCD BACKLIGHT)
LED254 6-500-681-01 LED SELU1910CXMLF38 (LCD BACKLIGHT)
< RESISTOR >
R101
R105
R106
R107
R108
1-216-841-11
1-216-835-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
15K
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R109
R110
R251
R252
R253
1-216-809-11
1-216-830-11
1-216-180-00
1-216-180-00
1-216-184-00
METAL CHIP
METAL CHIP
RES-CHIP
RES-CHIP
RES-CHIP
100
5.6K
180
180
270
5%
5%
5%
5%
5%
1/10W
1/10W
1/8W
1/8W
1/8W
R254
R255
R256
R257
R258
1-216-184-00
1-216-184-00
1-216-184-00
1-216-184-00
1-216-184-00
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
270
270
270
270
270
5%
5%
5%
5%
5%
1/8W
1/8W
1/8W
1/8W
1/8W
R340
R361
R362
R363
R364
1-216-835-11
1-216-833-11
1-216-843-11
1-216-835-11
1-216-848-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
15K
10K
68K
15K
180K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R365
R366
R367
R368
R369
1-216-833-11
1-216-833-11
1-216-843-11
1-216-835-11
1-216-848-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10K
68K
15K
180K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R370
R371
R372
R373
R374
1-216-833-11
1-216-833-11
1-216-843-11
1-216-835-11
1-216-848-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10K
68K
15K
180K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R375
1-216-833-11 METAL CHIP
10K
5%
1/10W
< SWITCH >
S301
1-786-396-11 SW, RTRY EC12E24604-30MM (VOLUME)
S302
1-478-082-11 ENCODER, ROTARY (BASS)
S303
1-478-082-11 ENCODER, ROTARY (TREBLE/MIDDLE)
**************************************************************
LED202 6-500-641-01 LED SLI-325URC (STANDBY/ON)
LED203 8-719-063-93 LED SLR325VC-N-T32 (i-Bass)
< RESISTOR >
R335
R336
R337
R338
R339
1-216-823-11
1-216-825-11
1-216-827-11
1-216-829-11
1-218-867-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
R345
R346
1-216-192-00 METAL CHIP
1-216-198-00 RES-CHIP
1.5K
2.2K
3.3K
4.7K
6.8K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
560
1K
5%
5%
1/8W
1/8W
< SWITCH >
S335
1-771-410-21 SWITCH, TACTILE (POWER 1)
S336
1-771-410-21 SWITCH, TACTILE (FUNCTION)
S337
1-771-410-21 SWITCH, TACTILE (BAND)
S338
1-771-410-21 SWITCH, TACTILE (GEQ)
S339
1-771-410-21 SWITCH, TACTILE (i-Bass)
**************************************************************
A-4733-389-A MAIN BOARD, COMPLETE (US)
A-4733-423-A MAIN BOARD, COMPLETE (E51, MX)
A-4733-440-A MAIN BOARD, COMPLETE (AEP. UK)
*********************
< CAPACITOR/SHORT >
C20
C007
C011
C012
C013
1-107-826-11
1-126-965-11
1-165-621-11
1-165-621-11
1-126-947-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT
0.1uF
22uF
0.1uF
0.1uF
47uF
10%
20%
20%
16V
50V
50V
50V
25V
C014
C015
C016
C017
C018
1-126-935-11
1-119-774-91
1-126-767-11
1-126-964-11
1-124-584-00
ELECT
ELECT
ELECT
ELECT
ELECT
470uF
100uF
1000uF
10uF
100uF
20%
20%
20%
20%
20%
16V
16V
16V
50V
10V
C019
C050
C052
C477
C501
1-119-772-11
1-126-964-11
1-126-947-11
1-126-963-11
1-124-261-91
ELECT
ELECT
ELECT
ELECT
ELECT
47uF
10uF
47uF
4.7uF
10uF
20%
20%
20%
20%
20%
25V
50V
25V
50V
50V
C502
C503
C504
C507
C508
1-124-261-00
1-126-963-11
1-126-963-11
1-107-826-11
1-107-826-11
ELECT
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
10uF
4.7uF
4.7uF
0.1uF
0.1uF
20%
20%
20%
10%
10%
50V
50V
50V
16V
16V
C517
1-164-156-11 CERAMIC CHIP
0.1uF
25V
103
CX-BK1
MAIN
Ref. No.
Part No.
Description
C518
C519
C601
C602
1-104-665-11
1-104-665-11
1-124-261-00
1-124-261-00
ELECT
ELECT
ELECT
ELECT
100uF
100uF
10uF
10uF
20%
20%
20%
20%
Remark
C603
C604
C606
C607
1-119-774-11
1-126-163-11
1-107-826-11
1-162-927-11
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
100uF
4.7uF
0.1uF
100PF
20%
20%
10%
5%
C608
1-162-927-11 CERAMIC CHIP
100PF
5%
C610
C611
C613
C614
C615
1-126-963-11
1-126-163-11
1-126-163-11
1-115-416-11
1-115-416-11
ELECT
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
4.7uF
4.7uF
4.7uF
0.001uF
0.001uF
20%
20%
20%
5%
5%
50V
50V
50V
25V
25V
C617
C618
C619
C621
C622
1-124-261-00
1-124-261-00
1-163-809-11
1-136-157-00
1-136-157-00
ELECT
ELECT
CERAMIC CHIP
FILM
FILM
10uF
10uF
0.047uF
0.022uF
0.022uF
20%
20%
10%
5%
5%
50V
50V
25V
50V
50V
C623
C624
C625
C626
C627
1-126-160-11
1-126-160-11
1-136-161-00
1-136-161-00
1-137-457-11
ELECT
ELECT
FILM
FILM
MYLAR
1uF
1uF
0.047uF
0.047uF
0.0027uF
20%
20%
5%
5%
5%
50V
50V
50V
50V
50V
C628
C629
C630
C631
C632
1-137-457-11
1-126-163-11
1-126-963-11
1-136-169-00
1-136-169-00
MYLAR
ELECT
ELECT
FILM
FILM
0.0027uF
4.7uF
4.7uF
0.22uF
0.22uF
5%
20%
20%
5%
5%
50V
50V
50V
50V
50V
C633
C634
C635
C636
C637
1-136-157-00
1-136-157-00
1-136-169-00
1-136-169-00
1-126-964-11
FILM
FILM
FILM
FILM
ELECT
0.022uF
0.022uF
0.22uF
0.22uF
10uF
5%
5%
5%
5%
20%
50V
50V
50V
50V
50V
C640
C641
C643
C645
C653
1-126-947-11
1-126-947-11
1-126-963-11
1-124-234-00
1-162-962-11
ELECT
ELECT
ELECT
ELECT
CERAMIC CHIP
47uF
47uF
4.7uF
22uF
470PF
20%
20%
20%
20%
10%
16V
16V
50V
16V
50V
C654
C655
C656
C657
1-164-388-11
1-164-388-11
1-107-826-11
1-119-774-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
270PF
270PF
0.1uF
100uF
5%
5%
10%
20%
50V
50V
16V
16V
10V
10V
50V
50V
16V
50V
16V
50V
(AEP, UK)
50V
(AEP, UK)
(US)
C657
1-126-933-11 ELECT
100uF
20%
16V
(EXCEPT US)
C661
C662
C663
C664
C665
1-162-960-11
1-162-960-11
1-124-261-00
1-124-261-00
1-164-816-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP
220PF
220PF
10uF
10uF
220PF
10%
10%
20%
20%
2%
C666
C668
1-164-816-11 CERAMIC CHIP
1-124-589-11 ELECT
220PF
47uF
2%
20%
C669
1-107-826-11 CERAMIC CHIP
0.1uF
10%
C675
1-164-245-11 CERAMIC CHIP
0.015uF
10%
104
50V
50V
50V
50V
50V
50V
16V
(AEP, UK)
16V
(AEP, UK)
25V
Ref. No.
Part No.
Description
Remark
C676
1-126-960-11 ELECT
1uF
20%
50V
C677
C682
C683
C684
C685
1-107-826-11
1-137-367-11
1-137-367-11
1-136-159-00
1-136-159-00
CERAMIC CHIP
MYLAR
MYLAR
FILM
FILM
0.1uF
0.0033uF
0.0033uF
0.033uF
0.033uF
10%
5%
5%
5%
5%
16V
50V
50V
50V
50V
C686
C687
C691
C692
C693
1-126-963-11
1-126-963-11
1-126-963-11
1-126-963-11
1-124-465-00
ELECT
ELECT
ELECT
ELECT
ELECT
4.7uF
4.7uF
4.7uF
4.7uF
0.47uF
20%
20%
20%
20%
20%
50V
50V
50V
50V
50V
C694
C696
C697
C700
C702
1-216-864-11
1-136-169-00
1-136-169-00
1-164-005-11
1-164-005-11
SHORT CHIP
FILM
FILM
CERAMIC CHIP
CERAMIC CHIP
0
0.22uF
0.22uF
0.47uF
0.47uF
5%
5%
50V
50V
25V
25V
C790
C791
C792
C866
1-162-927-11
1-162-927-11
1-162-927-11
1-126-964-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
100PF
100PF
100PF
10uF
5%
5%
5%
20%
C867
1-162-970-11 CERAMIC CHIP
0.01uF
10%
C872
C873
C876
C882
C883
1-162-967-11
1-162-967-11
1-126-963-11
1-126-963-11
1-126-963-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
ELECT
0.0033uF
0.0033uF
4.7uF
4.7uF
4.7uF
10%
10%
20%
20%
20%
50V
50V
50V
50V
50V
C892
C894
C901
C905
C906
1-126-947-11
1-164-156-11
1-104-665-11
1-162-964-11
1-162-964-11
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
47uF
0.1uF
100uF
0.001uF
0.001uF
20%
20%
10%
10%
16V
25V
10V
50V
50V
C908
C909
C910
C911
C912
1-162-964-11
1-162-977-11
1-162-918-11
1-162-919-11
1-164-670-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.001uF
0.0018uF
18PF
22PF
1200PF
10%
10%
5%
5%
5%
50V
50V
50V
50V
16V
C913
C914
C915
C916
C917
1-164-670-11
1-107-826-11
1-162-966-11
1-162-966-11
1-164-670-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
1200PF
0.1uF
0.0022uF
0.0022uF
1200PF
5%
10%
10%
10%
5%
16V
16V
50V
50V
16V
C918
C919
C920
C921
C922
1-164-670-11
1-164-670-11
1-115-156-11
1-115-156-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
1200PF
1200PF
1uF
1uF
0.1uF
5%
5%
10%
16V
16V
10V
10V
16V
C923
C924
C925
C926
C927
1-115-156-11
1-104-906-11
1-107-826-11
1-162-964-11
1-126-964-11
CERAMIC CHIP
DOUBLE LAYER
CERAMIC CHIP
CERAMIC CHIP
ELECT
1uF
0.22F
0.1uF
0.001uF
10uF
10%
10%
20%
10V
50V
16V
50V
50V
C928
C930
C931
C932
C933
1-126-965-11
1-162-964-11
1-126-964-11
1-107-826-11
1-128-551-11
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
22uF
0.001uF
10uF
0.1uF
22uF
20%
10%
20%
10%
20%
50V
50V
50V
16V
25V
50V
50V
50V
50V
(AEP, UK)
25V
(AEP, UK)
CX-BK1
MAIN
Ref. No.
Part No.
Description
C934
C935
C936
C938
C939
1-126-933-11
1-164-227-11
1-126-933-11
1-126-960-11
1-164-156-11
ELECT
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP
100uF
0.022uF
100uF
1uF
0.1uF
20%
10%
20%
20%
Remark
C940
C943
C944
C945
C946
1-126-767-11
1-162-964-11
1-162-964-11
1-107-826-11
1-162-927-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
1000uF
0.001uF
0.001uF
0.1uF
100PF
C948
C949
C950
C951
C952
1-162-927-11
1-162-927-11
1-162-927-11
1-162-927-11
1-162-927-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
C953
C954
C955
C956
C957
1-164-227-11
1-164-173-11
1-162-927-11
1-162-927-11
1-162-927-11
C958
C959
C960
C961
C962
1-162-964-11
1-162-964-11
1-162-964-11
1-162-964-11
1-162-964-11
C963
Ref. No.
Part No.
Description
Remark
16V
25V
16V
50V
25V
D910
8-719-423-10 DIODE MA8100-M-TX
D911
8-719-988-61 DIODE 1SS355TE-17
20%
10%
10%
10%
5%
16V
50V
50V
16V
50V
IC101
IC501
IC601
IC603
IC604
8-759-231-57
8-759-525-25
6-703-650-11
6-704-074-01
6-600-234-01
IC
IC
IC
IC
IC
TA7810S
BU4052BCF-E2
M61529FP-D60G
NJM2156M (TE2)
GP1FA313TZ (DIGITAL OPTICAL OUT)
(AEP. UK)
100PF
100PF
100PF
100PF
100PF
5%
5%
5%
5%
5%
50V
50V
50V
50V
50V
IC701
IC703
IC901
IC902
IC904
6-704-046-01
6-704-046-01
6-803-325-01
6-704-798-01
8-759-533-04
IC
IC
IC
IC
IC
BU2099FV
BU2099FV
uPD703260YGF-S04-JBT-A
BD4923G
M62703ML-E1
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.022uF
0.0039uF
100PF
100PF
100PF
10%
10%
5%
5%
5%
25V
50V
50V
50V
50V
IC905
6-704-135-01 IC MM1614A
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.001uF
0.001uF
0.001uF
0.001uF
0.001uF
10%
10%
10%
10%
10%
50V
50V
50V
50V
50V
1-162-964-11 CERAMIC CHIP
0.001uF
10%
50V
< IC >
< JACK >
JK602
JK603
1-779-902-21 JACK, PIN 4P (AUX IN/OUT)
1-774-227-11 JACK, PIN 1P (VIDEO OUT)
< SHORT >
< CONNECTOR >
JR001
JR002
JR501
JR502
JR503
1-216-296-00
1-216-296-00
1-216-864-11
1-216-296-00
1-216-864-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
CN004
CN006
CN007
CN009
CN502
1-784-778-11
1-564-509-11
1-564-507-11
1-568-830-11
1-784-733-11
CONNECTOR, FFC 17P
PLUG, CONNECTOR 6P
PLUG, CONNECTOR 4P
CONNECTOR, FFC 11P (EXCEPT US)
CONNECTOR, FFC 11P
JR601
JR607
JR610
JR611
JR612
1-216-296-00
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
CN504
CN507
CN508
CN509
CN901
1-784-766-11
1-779-279-11
1-784-776-11
1-568-830-11
1-779-295-11
CONNECTOR, FFC 5P (E51, MX)
CONNECTOR, FFC (LIF (NON-ZIF)) 11P
CONNECTOR, FFC 15P (AEP. UK)
CONNECTOR, FFC 11P (EXCEPT AEP, UK)
CONNECTOR, FFC (LIF (NON-ZIF)) 27P
JR613
JR614
JR615
JR616
JR617
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
CN902
CN903
CN905
CN999
1-779-291-11
1-691-040-31
1-784-780-11
1-568-826-11
CONNECTOR, FFC (LIF (NON-ZIF)) 23P
CONNECTOR, FFC 8P (EXCEPT US)
CONNECTOR, FFC 19P
CONNECTOR, FFC 7P
JR620
JR621
JR624
JR701
JR702
1-216-864-11
1-216-864-11
1-216-864-11
1-216-296-00
1-216-864-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0 (US, AEP, UK)
0
0
JR703
JR704
JR705
JR706
JR707
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
JR708
JR709
JR801
JR802
JR901
1-216-864-11
1-216-864-11
1-216-296-00
1-216-864-11
1-216-864-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
JR902
JR903
JR904
JR905
JR906
1-216-864-11
1-216-864-11
1-216-296-00
1-216-296-00
1-216-296-00
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
< DIODE >
D015
D016
D017
D018
D050
8-719-421-18
8-719-988-61
8-719-988-61
8-719-988-61
8-719-988-61
DIODE
DIODE
DIODE
DIODE
DIODE
MA8033-L-TX
1SS355TE-17
1SS355TE-17
1SS355TE-17
1SS355TE-17
D501
D611
D612
D613
D902
8-719-083-58
8-719-988-61
8-719-988-61
8-719-988-61
8-719-988-61
DIODE
DIODE
DIODE
DIODE
DIODE
UDZSTE-173.9B
1SS355TE-17
1SS355TE-17
1SS355TE-17
1SS355TE-17
D904
D905
D906
D907
8-719-988-61
8-719-988-61
8-719-988-61
8-719-988-61
DIODE
DIODE
DIODE
DIODE
1SS355TE-17
1SS355TE-17
1SS355TE-17
1SS355TE-17 (EXCEPT US)
105
CX-BK1
MAIN
Ref. No.
JR907
JR908
Part No.
Description
1-216-864-11 SHORT CHIP
1-216-864-11 SHORT CHIP
Remark
0
0 (AEP, UK)
< SHORT >
L901
1-216-365-11 SHORT CHIP
0
Ref. No.
Part No.
Description
Remark
R515
1-216-837-11 METAL CHIP
22K
5%
1/10W
R516
R517
R518
R520
R521
1-216-837-11
1-216-174-11
1-216-174-11
1-216-853-11
1-216-864-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
22K
100
100
470K
0
5%
5%
5%
5%
1/10W
1/8W
1/8W
1/10W
R522
R523
R524
R525
R526
1-216-864-11
1-216-864-11
1-216-864-11
1-216-809-11
1-216-809-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
0
0
0
100
100
5%
5%
1/10W
1/10W
R527
R528
R529
R530
R531
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R601
R602
R603
R604
R605
1-216-829-11
1-216-829-11
1-216-837-11
1-216-837-11
1-216-838-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
4.7K
22K
22K
27K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R606
R607
R609
R610
R613
1-216-838-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
METAL CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
27K
5%
0
0
0
0 (EXCEPT US)
1/10W
R614
R615
R616
R617
R618
1-216-864-11
1-216-864-11
1-216-864-11
1-216-825-11
1-216-825-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
0 (EXCEPT US)
0
0
2.2K
5%
2.2K
5%
1/10W
1/10W
R619
R620
R621
R622
R623
1-216-821-11
1-216-821-11
1-216-835-11
1-216-835-11
1-216-825-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
15K
15K
2.2K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R624
R625
R626
R627
1-216-825-11
1-216-833-11
1-216-833-11
1-216-829-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
10K
10K
4.7K
5%
5%
5%
5%
R628
1-216-837-11 METAL CHIP
22K
5%
1/10W
1/10W
1/10W
1/10W
(E51, MX)
1/10W
R629
R630
R635
R636
R639
1-216-150-00
1-216-833-11
1-216-842-11
1-216-838-11
1-216-821-11
RES-CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10
10K
56K
27K
1K
5%
5%
5%
5%
5%
1/8W
1/10W
1/10W
1/10W
1/10W
R640
R641
R642
R643
R644
1-216-861-11
1-216-861-11
1-216-822-11
1-216-822-11
1-216-825-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2M
2.2M
1.2K
1.2K
2.2K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R645
R647
R648
R649
R650
1-216-825-11
1-216-829-11
1-216-829-11
1-216-864-11
1-216-864-11
METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
SHORT CHIP
2.2K
4.7K
4.7K
0
0
5%
5%
5%
1/10W
1/10W
1/10W
< TRANSISTOR >
Q25
Q018
Q019
Q024
Q050
8-729-027-46
8-729-120-28
8-729-024-93
8-729-801-84
8-729-120-28
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTC114YKA-T146
2SC3052F-T1-LF
2SB1370-E
2SB1013-TP-34
2SC3052F-T1-LF
Q051
Q602
Q604
Q605
Q607
8-729-201-53
8-729-120-28
8-729-052-79
8-729-120-28
8-729-052-79
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SA1015TP-GR
2SC3052F-T1-LF
2SD1306NE
2SC3052F-T1-LF
2SD1306NE
Q608
Q614
Q615
Q616
Q617
6-550-580-01
8-729-045-62
8-729-045-62
8-729-045-62
8-729-045-62
TRANSISTOR
FET
FET
FET
FET
2SA1235TP-1F
2SK2158-T2B
2SK2158-T2B
2SK2158-T2B
2SK2158-T2B
Q618
Q619
Q620
Q623
Q624
8-729-045-62
8-729-045-62
8-729-045-62
8-729-120-28
8-729-045-62
FET
FET
FET
TRANSISTOR
FET
2SK2158-T2B
2SK2158-T2B
2SK2158-T2B
2SC3052F-T1-LF
2SK2158-T2B
Q625
Q890
Q891
Q892
Q901
8-729-120-28
8-729-037-03
8-729-120-28
8-729-120-28
8-729-027-23
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC3052F-T1-LF
KTA1266GR-AT
2SC3052F-T1-LF
2SC3052F-T1-LF
DTA114EKA-T146
Q902
Q904
Q905
8-729-120-28 TRANSISTOR
8-729-116-57 TRANSISTOR
8-729-140-04 TRANSISTOR
Q906
1-801-806-11 TRANSISTOR
2SC3052F-T1-LF
2SB1068TP-K (EXCEPT US)
2SB1116A-TP-LK
(EXCEPT US)
DTC144EKA-T146
< RESISTOR >
R003
R011
R016
R017
R018
1-216-296-00
1-216-134-00
1-249-413-11
1-216-841-11
1-216-809-11
SHORT CHIP
METAL CHIP
CARBON
METAL CHIP
METAL CHIP
0
2.2
470
47K
100
R019
R020
R031
R032
R038
1-216-817-11
1-216-864-11
1-216-817-11
1-216-841-11
1-249-409-11
METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
CARBON
470
0
470
47K
220
R050
R052
R053
R509
R510
1-216-845-11
1-216-832-11
1-216-836-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
R511
R512
R513
R514
1-216-837-11
1-216-837-11
1-216-837-11
1-216-837-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
106
5%
5%
5%
5%
1/8W
1/4W
1/10W
1/10W
5%
1/10W
5%
5%
5%
1/10W
1/10W
1/4W
100K
8.2K
18K
10K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
22K
22K
22K
22K
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
CX-BK1
MAIN
Ref. No.
Part No.
Description
R651
R652
R655
R656
R657
1-216-845-11
1-216-845-11
1-216-824-11
1-216-830-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
100K
4.7K
5.6K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
Remark
R658
R659
R660
R662
R663
1-216-820-11
1-216-825-11
1-216-825-11
1-216-864-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
METAL CHIP
820
2.2K
3.3K
0
10K
5%
5%
5%
1/10W
1/10W
1/10W
5%
1/10W
R664
R665
R666
R667
R668
1-216-836-11
1-216-857-11
1-216-814-11
1-216-833-11
1-216-829-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
18K
1M
270
10K
4.7K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R669
R670
R671
R672
R674
1-216-829-11
1-216-809-11
1-216-809-11
1-216-829-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
100
100
4.7K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R675
R676
R677
R678
R679
1-216-825-11
1-216-825-11
1-216-837-11
1-216-849-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
2.2K
22K
220K
100K
5%
5%
5%
5%
5%
1/10
1/10
1/10W
1/10W
1/10W
R680
R681
R682
R683
R684
1-216-849-11
1-216-849-11
1-216-841-11
1-216-844-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
220K
220K
47K
82K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R685
R686
R687
R688
R689
1-216-841-11
1-216-832-11
1-216-823-11
1-216-823-11
1-216-214-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
RES-CHIP
47K
8.2K
1.5K
1.5K
4.7K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/8W
R692
R693
R694
R695
R696
1-216-809-11
1-216-809-11
1-216-826-11
1-216-826-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
2.7K
2.7K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R697
R698
R699
R701
R702
1-216-845-11
1-216-830-11
1-216-830-11
1-216-849-11
1-216-841-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
5.6K
5.6K
220K
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R703
R704
R707
R708
R709
1-216-821-11
1-216-821-11
1-216-833-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
10K
10K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R710
R711
R712
R713
R714
1-216-833-11
1-216-833-11
1-216-821-11
1-216-821-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10K
1K
1K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R715
R716
R717
1-216-833-11 METAL CHIP
1-216-833-11 METAL CHIP
1-216-833-11 METAL CHIP
10K
10K
10K
5%
5%
5%
1/10W
1/10W
1/10W
Ref. No.
Part No.
Description
Remark
R718
R719
1-216-833-11 METAL CHIP
1-216-833-11 METAL CHIP
10K
10K
5%
5%
1/10W
1/10W
R721
R722
R723
R724
R725
1-216-833-11
1-216-833-11
1-216-821-11
1-216-821-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10K
1K
1K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R726
R727
R728
R729
R730
1-216-821-11
1-216-833-11
1-216-833-11
1-216-833-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
10K
10K
10K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R731
R732
R733
R734
R737
1-216-825-11
1-216-825-11
1-216-821-11
1-216-821-11
1-216-825-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
2.2K
1K
1K
2.2K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R738
R739
R740
R741
R744
1-216-821-11
1-216-821-11
1-216-821-11
1-216-821-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
1K
1K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R745
R746
R747
R748
R749
1-216-821-11
1-216-821-11
1-216-821-11
1-216-821-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
1K
1K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R750
R751
R752
R753
R754
1-216-821-11
1-216-821-11
1-216-825-11
1-216-821-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
2.2K
1K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R755
R756
R759
R760
R761
1-216-829-11
1-216-829-11
1-216-829-11
1-216-826-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
4.7K
4.7K
2.7K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R762
R763
1-216-826-11 METAL CHIP
1-216-841-11 METAL CHIP
2.7K
47K
5%
5%
R764
R765
R766
1-216-826-11 METAL CHIP
1-216-830-11 METAL CHIP
1-216-826-11 METAL CHIP
2.7K
5.6K
2.7K
R767
R768
R769
R770
R771
1-216-830-11
1-216-833-11
1-216-830-11
1-216-864-11
1-216-864-11
METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
SHORT CHIP
5.6K
10K
5.6K
0
0
R772
R773
R774
R778
R779
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
R780
R781
R782
R783
R784
1-216-864-11
1-216-864-11
1-216-841-11
1-216-841-11
1-216-841-11
SHORT CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
0
47K
47K
47K
1/10W
1/10W
(EXCEPT US)
5%
1/10W
5%
1/10W
5%
1/10W
5%
5%
5%
1/10W
1/10W
1/10W
5%
5%
5%
1/10W
1/10W
1/10W
107
CX-BK1
MAIN
Ref. No.
Part No.
R785
R786
R787
R788
R789
1-216-841-11
1-216-841-11
1-216-841-11
1-216-841-11
1-216-841-11
R863
Description
Ref. No.
Part No.
Description
R937
R938
R939
R940
1-216-809-11
1-216-809-11
1-216-809-11
1-216-826-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
2.7K
5%
5%
5%
5%
Remark
1/10W
1/10W
1/10W
1/10W
R941
R942
R943
R944
1-216-847-11
1-216-843-11
1-216-864-11
1-216-833-11
METAL CHIP
METAL CHIP
SHORT CHIP
METAL CHIP
150K
5%
68K
5%
0 (EXCEPT US)
10K
5%
1/10W
1/10W
R945
1-216-829-11 METAL CHIP
4.7K
R945
1-216-833-11 METAL CHIP
10K
5%
R945
1-216-847-11 METAL CHIP
150K
5%
R946
R947
R950
1-216-864-11 SHORT CHIP
1-216-821-11 METAL CHIP
1-216-864-11 SHORT CHIP
0
1K
0
5%
1/10W
R951
R952
R953
R954
R955
1-216-833-11
1-216-845-11
1-216-845-11
1-216-833-11
1-216-049-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
RES-CHIP
10K
100K
100K
10K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R957
R958
R959
R960
R961
1-216-864-11
1-216-840-11
1-216-053-00
1-216-849-11
1-216-065-00
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
RES-CHIP
0
39K
1.5K
220K
4.7K
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
R962
R967
R968
R969
R970
1-216-833-11
1-216-025-11
1-216-821-11
1-216-838-11
1-216-864-11
METAL CHIP
RES-CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
10K
100
1K
27K
0
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
R980
R981
R982
R983
R984
1-216-829-11
1-216-817-11
1-216-845-11
1-216-845-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
470
100K
100K
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R985
1-216-821-11 METAL CHIP
1K
5%
R986
1-216-821-11 METAL CHIP
1K
5%
R987
1-216-821-11 METAL CHIP
1K
5%
R988
1-216-821-11 METAL CHIP
1K
5%
R989
1-216-841-11 METAL CHIP
47K
5%
5%
47K
47K
47K
47K
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
1-216-807-11 METAL CHIP
68
5%
R879
R880
R881
R884
1-216-821-11
1-216-830-11
1-216-841-11
1-216-828-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
5.6K
47K
3.9K
5%
5%
5%
5%
1/10W
(AEP, UK)
1/10W
1/10W
1/10W
1/10W
R885
R887
R888
R890
R891
1-216-828-11
1-216-830-11
1-216-809-11
1-216-841-11
1-216-825-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
3.9K
5.6K
100
47K
2.2K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R892
R893
R894
R895
R896
1-216-825-11
1-216-833-11
1-216-864-11
1-216-825-11
1-216-826-11
METAL CHIP
METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
2.2K
10K
0
2.2K
2.7K
5%
5%
1/10W
1/10W
5%
5%
1/10W
1/10W
R901
R902
R903
R904
R905
1-216-841-11
1-216-841-11
1-216-841-11
1-216-841-11
1-216-841-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
47K
47K
47K
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R906
R907
R908
R909
R910
1-216-841-11
1-216-841-11
1-216-841-11
1-216-841-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
47K
47K
47K
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R911
R912
R913
R914
R915
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R916
R917
R918
R919
R920
1-216-841-11
1-216-825-11
1-216-841-11
1-216-841-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
2.2K
47K
47K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R921
R922
R923
R924
R925
1-216-841-11
1-216-841-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
47K
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R926
R927
R928
R929
R930
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R990
1-216-841-11 METAL CHIP
47K
R991
1-216-841-11 METAL CHIP
47K
R992
1-216-841-11 METAL CHIP
47K
R931
R932
R933
R934
R935
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R995
1-216-833-11 METAL CHIP
10K
R995
1-216-857-11 METAL CHIP
1M
R996
1-216-833-11 METAL CHIP
10K
R936
1-216-809-11 METAL CHIP
100
5%
1/10W
108
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
Remark
1/10W
(EXCEPT US)
5%
1/10W
(E51, MX)
1/10W
(US)
1/10W
(AEP, UK)
1/10W
(EXCEPT US)
1/10W
(EXCEPT US)
1/10W
(EXCEPT US)
1/10W
(EXCEPT US)
1/10W
(EXCEPT US)
1/10W
(EXCEPT US)
5%
1/10W
(EXCEPT US)
5%
1/10W
(EXCEPT US)
5%
1/10W
(US, E51, MX)
5%
1/10W
(AEP, UK)
5%
1/10W
(US, E51, MX)
CX-BK1
MAIN
Ref. No.
Part No.
MIC
Description
MODE MOTOR
Remark
R996
R997
1-216-864-11 SHORT CHIP
1-216-833-11 METAL CHIP
R997
R998
1-216-864-11 SHORT CHIP
1-220-397-11 METAL CHIP
0 (AEP, UK)
10K
5%
1/10W
(US, E51, MX)
0 (AEP, UK)
4.7M
5%
1/10W
R999
1-216-851-11 METAL CHIP
330K
5%
Ref. No.
1/10W
Part No.
PT
RIGHT BUTTON (1)
Description
Remark
R204
R205
1-216-809-11 METAL CHIP
1-216-825-11 METAL CHIP
100
2.2K
5%
5%
1/10W
1/10W
R206
R207
R208
R209
R210
1-216-850-11
1-216-821-11
1-216-174-00
1-216-817-11
1-216-825-11
METAL CHIP
METAL CHIP
RES-CHIP
METAL CHIP
METAL CHIP
270K
1K
100
470
2.2K
5%
5%
5%
5%
5%
1/10W
1/10W
1/8W
1/10W
1/10W
R211
R212
R213
R214
R215
1-216-825-11
1-216-825-11
1-216-839-11
1-216-797-11
1-216-817-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
2.2K
33K
10
470
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R216
R232
1-216-821-11 METAL CHIP
1-216-833-11 METAL CHIP
1K
10K
5%
5%
1/10W
1/10W
< VIBRATOR >
X901
1-760-252-12 VIBRATOR, CRYSTAL (32.768kHz)
X902
1-795-058-21 VIBRATOR, CERAMIC (5MHz)
**************************************************************
A-4733-419-A MIC BOARD, COMPLETE (E51, MX)
********************
< CAPACITOR >
< VARIABLE RESISTOR >
C203
C204
C205
C206
C207
1-162-968-11
1-126-957-11
1-126-964-11
1-126-934-11
1-162-928-11
CERAMIC CHIP
ELECT
ELECT
ELECT
CERAMIC CHIP
0.0047uF
0.22uF
10uF
220uF
120PF
10%
20%
20%
20%
5%
50V
50V
50V
10V
50V
C208
C209
C210
C211
C212
1-126-960-11
1-126-964-11
1-126-965-11
1-164-473-11
1-126-959-11
ELECT
ELECT
ELECT
CERAMIC CHIP
ELECT
1uF
10uF
22uF
820PF
0.47uF
20%
20%
20%
5%
20%
50V
50V
50V
50V
50V
C213
C216
C219
1-126-961-11 ELECT
1-126-959-11 ELECT
1-115-467-11 CERAMIC CHIP
2.2uF
0.47uF
0.22uF
20%
20%
10%
50V
50V
10V
VR201 1-227-502-11 RES, VAR, CARBON 10K (MIC MIXING)
**************************************************************
1-686-724-12 MODE MOTOR BOARD
******************
**************************************************************
1-688-417-11 PT BOARD (US, AEP, UK)
1-688-421-11 PT BOARD (E51, MX)
*********
< CAPACITOR >
C009
1-164-005-11 CERAMIC CHIP
0.47uF
C025
1-164-005-11 CERAMIC CHIP
0.47uF
25V
(E51, MX)
25V
(US, AEP, UK)
< CONNECTOR >
CN205
1-784-766-11 CONNECTOR, FFC 5P
< CONNECTOR >
< DIODE >
D201
D202
8-719-988-61 DIODE 1SS355TE-17
8-719-988-61 DIODE 1SS355TE-17
*
*
*
*
< FERRITE BEAD >
* FB201
1-543-959-22 FERRITE
CN001
CN007
CN008
CN010
* CN011
0uH
1-564-915-11
1-564-687-11
1-564-687-11
1-564-321-21
PIN, CONNECTOR (3.96mm PITCH) 7P (US)
PIN, CONNECTOR (3.96mm PITCH) 3P (E51)
PIN, CONNECTOR (3.96mm PITCH) 3P (E51)
PIN, CONNECTOR (3.96mm PITCH) 2P
(EXCEPT E51)
1-564-242-00 PIN, CONNECTOR (3.96mm PITCH) 5P
(AEP, UK)
< IC >
* CN015
IC201
1-564-915-11 PIN, CONNECTOR (3.96mm PITCH) 7P
(E51, MX)
**************************************************************
8-759-710-97 IC NJM4565M (TE2)
< JACK >
J201
1-688-408-11 RIGHT BUTTON (1) BOARD
**********************
1-816-860-11 JACK, 6.3 BLK MONO W/SW V MSC (MIC)
< RESISTOR >
< SHORT >
JR204
1-216-864-11 SHORT CHIP
R341
R342
R343
R344
0
< TRANSISTOR >
Q201
8-729-045-62 FET
1-216-816-11
1-216-819-11
1-216-821-11
1-216-823-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
390
680
1K
1.5K
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
2SK2158-T2B
< SWITCH >
< RESISTOR >
R201
R202
R203
1-216-833-11 METAL CHIP
1-216-829-11 METAL CHIP
1-216-849-11 METAL CHIP
10K
4.7K
220K
5%
5%
5%
1/10W
1/10W
1/10W
S341
1-771-410-21 SWITCH, TACTILE (TITLE)
S342
1-771-410-21 SWITCH, TACTILE (DISPLAY)
S343
1-771-410-21 SWITCH, TACTILE (MODE)
**************************************************************
109
CX-BK1
SPEAKER
Ref. No.
Part No.
RIGHT BUTTON (2)
STOCKER
SW (1)
Description
ROLLER MOTOR
SENSOR
SW (3)
USB AUX
SW (2)
Remark
Ref. No.
Part No.
SW (4)
Description
Remark
1-686-727-12 SW (1) BOARD
************
1-688-409-11 RIGHT BUTTON (2) BOARD
**********************
< SWITCH >
< SWITCH >
S711
S344
1-771-410-21 SWITCH, TACTILE (ENTER)
**************************************************************
1-786-382-11 SWITCH, PUSH (1 KEY)
(DISC INSERT (8/12cm))
**************************************************************
1-686-726-12 ROLLER MOTOR BOARD
********************
1-686-728-12 SW (2) BOARD
************
< SWITCH >
**************************************************************
1-686-723-12 SENSOR BOARD
*************
S713
1-786-382-11 SWITCH, PUSH (1 KEY) (DISC IN (8/12cm))
S714
1-786-382-11 SWITCH, PUSH (1 KEY) (DISC IN (8cm))
**************************************************************
< IC >
1-686-729-12 SW (3) BOARD
************
IC751
8-749-017-45 SENSOR, PHONT RPR-220C1N
(DISC INSERT DETECT SENSOR)
**************************************************************
1-688-419-11 SPEAKER BOARD
***************
< SWITCH >
S715
1-786-382-11 SWITCH, PUSH (1 KEY) (DISC OUT)
**************************************************************
< CAPACITOR >
1-686-730-12 SW (4) BOARD
************
C524
C525
C526
C527
C532
1-165-621-11
1-165-621-11
1-165-621-11
1-165-621-11
1-162-966-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.1uF
0.0022uF 10%
50V
50V
50V
50V
50V
C533
C534
C535
1-162-966-11 CERAMIC CHIP
1-165-621-11 CERAMIC CHIP
1-165-621-11 CERAMIC CHIP
0.0022uF 10%
0.1uF
0.1uF
50V
50V
50V
< SWITCH >
S716
1-786-382-11 SWITCH, PUSH (1 KEY) (STOCKER IN/OUT)
S717
1-786-382-11 SWITCH, PUSH (1 KEY) (DISC POSITION)
S718
1-786-382-11 SWITCH, PUSH (1 KEY) (STOCKING)
**************************************************************
A-4733-399-A USB AUX BOARD, COMPLETE
************************
< CONNECTOR >
< CAPACITOR >
* CN503
1-564-241-11 PIN, CONNECTOR (3.96mm PITCH) 4P
< JACK >
JK502
1-694-635-12 TERMINAL BOARD (4P) (5 SPEAKER)
C700
C701
C702
C703
C704
1-162-919-11
1-162-919-11
1-162-964-11
1-162-964-11
1-162-960-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
22PF
22PF
0.001uF
0.001uF
220PF
5%
5%
10%
10%
10%
50V
50V
50V
50V
50V
C705
C706
C708
C709
C710
1-162-960-11
1-162-970-11
1-117-863-11
1-164-156-11
1-164-156-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
220PF
0.01uF
0.47uF
0.1uF
0.1uF
10%
10%
10%
50V
25V
6.3V
25V
25V
C711
C712
C713
C714
C715
1-162-919-11
1-125-891-11
1-126-964-11
1-162-919-11
1-104-665-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
22PF
0.47uF
10uF
22PF
100uF
5%
10%
20%
5%
20%
50V
10V
50V
50V
10V
C716
C717
C718
C719
C720
1-126-964-11
1-104-663-11
1-164-360-11
1-164-156-11
1-164-156-11
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
10uF
33uF
0.1uF
0.1uF
0.1uF
20%
20%
50V
25V
16V
25V
25V
C721
C722
C724
C725
1-164-156-11
1-164-156-11
1-162-927-11
1-162-927-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
100PF
100PF
< COIL >
L501
L502
1-420-872-52 COIL, AIR-CORE
1-420-872-52 COIL, AIR-CORE
< RESISTOR >
R570
1-249-625-31 CARBON
10
5%
1/2W
R571
1-249-625-31 CARBON
10
5%
1/2W
R572
1-249-393-11 CARBON
10
5%
1/4W
R573
1-249-393-11 CARBON
10
5%
1/4W
**************************************************************
1-686-725-12 STOCKER MOTOR BOARD
*********************
**************************************************************
110
5%
5%
25V
25V
50V
50V
CX-BK1
USB AUX
Ref. No.
Part No.
Description
Remark
C755
1-162-927-11 CERAMIC CHIP
100PF
5%
50V
C756
C757
C758
C759
C760
1-126-963-11
1-164-222-11
1-104-665-11
1-126-947-11
1-164-005-11
ELECT
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP
4.7uF
0.22uF
100uF
47uF
0.47uF
20%
50V
25V
10V
10V
25V
C762
1-164-222-11 CERAMIC CHIP
0.22uF
20%
20%
25V
Ref. No.
Part No.
Description
R716
R718
R720
R721
1-216-827-11
1-216-827-11
1-216-827-11
1-216-827-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
3.3K
3.3K
3.3K
3.3K
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
Remark
R722
R723
R724
R725
R726
1-216-829-11
1-216-821-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
1K
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R727
R728
R729
R730
R731
1-216-809-11
1-216-809-11
1-216-819-11
1-216-819-11
1-216-803-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
680
680
33
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R732
R735
R736
1-216-845-11 METAL CHIP
1-216-837-11 METAL CHIP
1-216-837-11 METAL CHIP
100K
22K
22K
5%
5%
5%
1/10W
1/10W
1/10W
< CONNECTOR >
CN701
1-784-778-11 CONNECTOR, FFC 17P
< GROUND TERMINAL >
* EP701
* EP702
1-537-738-21 TERMINAL, EARTH
1-537-738-21 TERMINAL, EARTH
< IC >
IC700
IC701
6-704-219-01 IC UAC3553B
8-759-701-56 IC NJM78M05FA
< VIBRATOR >
X700
1-578-774-81 VIBRATOR, CRYSTAL (12MHz)
************************************************************
< JACK >
* J700
J701
1-784-010-11 CONNECTOR, USB (B) (USB)
1-779-583-11 JACK, PIN 3P (LINE IN)
MISCELLANEOUS
**************
< SHORT >
JR701
JR702
JR703
1-216-864-11 SHORT CHIP
1-216-864-11 SHORT CHIP
1-216-864-11 SHORT CHIP
51
0
0
0
59
60
102
153
1-796-351-61 MECHANISM, SIGNAL CASSETTE
(CMAL1Z241A) (EXCEPT US)
1-765-326-11 WIRE (FLAT TYPE) (11 CORE) (EXCEPT US)
1-827-677-11 WIRE (FLAT TYPE) (8 CORE) (EXCEPT US)
1-769-869-11 WIRE (FLAT TYPE) (5 CORE) (E51, MX)
1-773-115-11 WIRE (FLAT TYPE) (19 CORE)
154
254
255
255
257
1-773-156-11
1-765-334-11
1-769-943-11
1-773-007-11
1-693-625-11
WIRE (FLAT TYPE) (21 CORE)
WIRE (FLAT TYPE) (17 CORE)
WIRE (FLAT TYPE) (11 CORE) (US, E51, MX)
WIRE (FLAT TYPE) (15 CORE) (AEP, UK)
TUNER (FM/AM) (US)
257
257
258
259
260
1-693-626-11
1-693-628-11
1-769-944-11
1-827-488-11
1-827-489-11
TUNER (FM/AM) (AEP, UK)
TUNER (FM/AM) (E51, MX)
WIRE (FLAT TYPE) (11 CORE)
WIRE (FLAT TYPE) (27 CORE)
WIRE (FLAT TYPE) (11 CORE)
261
0 303
0 303
0 303
0 807
1-775-217-11
1-777-071-83
1-783-532-11
1-827-226-11
A-4735-189-A
WIRE (FLAT TYPE) (23 CORE)
CORD, POWER (AEP, UK, E51)
CORD, POWER (US)
CORD, POWER (MX)
BU-30 (61) ASSY
808
0 F001
0 F001
1-782-817-11 WIRE (FLAT TYPE) (16 CORE)
1-533-453-12 FUSE, GLASS TUBE (DIA. 5) (5A/125V) (US)
1-533-472-11 FUSE, GLASS TUBE (DIA. 5) (5A/250V)
(E51, MX)
1-763-072-11 FAN, DC
A-4735-953-A MOTOR ASSY (STOCKER)
< FERRITE>
JN702
JN704
1-410-396-41 FERRITE
1-410-396-41 FERRITE
0.45uH
0.45uH
< COIL >
L700
L701
L702
L703
L705
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
< TRANSISTOR >
Q700
Q701
Q702
8-729-900-53 TRANSISTOR
8-729-106-60 TRANSISTOR
8-729-027-23 TRANSISTOR
DTC114EKA-T146
2SB1132-T101-R
DTA114EKA-T146
< RESISTOR >
R700
R701
R702
R703
R704
1-216-801-11
1-216-801-11
1-216-835-11
1-216-835-11
1-216-832-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
22
22
15K
15K
8.2K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R705
R706
R707
R710
R711
1-216-832-11
1-216-835-11
1-216-835-11
1-216-849-11
1-216-829-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
8.2K
15K
15K
220K
4.7K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R712
1-216-829-11 METAL CHIP
4.7K
5%
1/10W
The components identified by mark 0 or dotted
line with mark 0 are critical for safety.
Replace only with part number specified.
M301
M761
M771
M781
0 PT001
0 PT002
0 PT003
A-4735-953-A
A-4735-953-A
1-439-796-11
1-439-795-11
1-439-794-11
MOTOR ASSY (MODE)
MOTOR ASSY (ROLLER)
TRANSFORMER, POWER (MX)
TRANSFORMER, POWER (E51)
TRANSFORMER, POWER (US)
0 PT003
Q531
1-439-797-11 TRANSFORMER, POWER (AEP, UK)
6-550-291-01 TRANSISTOR FN1016 (AEP, UK)
111
CX-BK1
Ref. No.
Part No.
Description
Q531
Q531
Q532
6-550-320-01 TRANSISTOR 2SD2562 (E51, MX)
8-729-020-52 TRANSISTOR 2SD2439-OPY (US)
6-550-291-01 TRANSISTOR FN1016 (AEP, UK)
Q532
Q532
Q533
Q533
Q533
6-550-320-01
8-729-020-52
6-550-292-01
6-550-319-01
8-729-020-48
Remark
Ref. No.
Part No.
Description
Remark
TRANSISTOR 2SD2562 (E51, MX)
TRANSISTOR 2SD2439-OPY (US)
TRANSISTOR FP1016 (AEP, UK)
TRANSISTOR 2SB1649 (E51, MX)
TRANSISTOR 2SB1588-OPY (US)
Q534
6-550-292-01 TRANSISTOR FP1016 (AEP, UK)
Q534
6-550-319-01 TRANSISTOR 2SB1649 (E51, MX)
Q534
8-729-020-48 TRANSISTOR 2SB1588-OPY (US)
S702
1-477-299-11 ENCODER, ROTARY (STOCKER POSITION)
S771
1-477-300-11 ENCODER, ROTARY (MODE)
************************************************************
ACCESSORIES
************
0
0
112
1-569-008-12 ADAPTOR, CONVERSION 2P (E51)
1-770-019-51 ADAPTOR, CONVERSION PLUG (UK)
The components identified by mark 0 or dotted
line with mark 0 are critical for safety.
Replace only with part number specified.
CX-BK1
MEMO
113
CX-BK1
REVISION HISTORY
Clicking the version allows you to jump to the revised page.
Also, clicking the version at the upper right on the revised page allows you to jump to the next revised
page.
Ver.
1.0
Date
2003.06
Description of Revision
New

Top types

Top brands

Top types

Top brands

Top types

Top brands

Top types

Top brands

Top types

Top brands

Top types

Top brands

Top types

Top brands

Top types

Top brands

Top types

Top brands

Top types

Top brands

Top types

Top brands

Top types

Top brands

Top types

Top brands

Download SERVICE MANUAL COMPACT DISC RECEIVER US model