Download TS-480 Service Manual

HF / 50MHz ALL MODE TRANSCEIVER
TS-480HX/480SAT
SERVICE MANUAL
© 2003-11 PRINTED IN JAPAN
B51-8667-00 (N) 694
Cabinet (Upper)
(A01-2189-02)
Microphone
(T91-0638-05)
Knob
(K29-9265-03)
Panel assy
(A62-1076-03)
Knob
(K29-9267-03)
Key top
(K29-9263-02)
Knob
(K29-9266-03)
Knob ring
(K29-9264-04)
Stand
(J09-0409-03)
Knob
(K29-9270-03)
Knob (Main dial)
(K21-1105-03)
Panel
(A62-1079-01)
Foot
(J02-0441-05) x 4
Knob
(K29-9267-03)
Cabinet (Lower)
(A01-2190-02)
CONTENTS
DISASSEMBLY FOR REPAIR .................................. 2
CIRCUIT DESCRIPTION ........................................... 3
COMPONENTS DESCRIPTION ............................. 14
SEMICONDUCTOR DATA ..................................... 20
PARTS LIST ............................................................ 27
EXPLODED VIEW ................................................... 50
PACKING ................................................................ 54
ADJUSTMENT ....................................................... 55
INTERCONNECTION DIAGRAM ........................... 76
PC BOARD / SCHEMATIC DIAGRAM
RF UNIT (X44-327X-XX) .................................... 78
FINAL UNIT (X45-365X-XX) (A/3) ..................... 86
FINAL UNIT (X45-365X-XX) (B/3) ..................... 93
FINAL UNIT (X45-365X-XX) (C/3) ..................... 96
FINAL UNIT (X45-366X-XX) (A/3) ..................... 98
FINAL UNIT (X45-366X-XX) (B/3) ................... 105
FINAL UNIT (X45-366X-XX) (C/3) ................... 108
DISPLAY UNIT (X54-3410-00) (A/3, B/3, C/3) ....... 110
TX-RX UNIT (X57-663X-XX) (A/2, B/2) .......... 116
SUB UNIT (X58-4900-XX) ................................ 128
TERMINAL FUNCTION ........................................ 129
BLOCK DIAGRAM ................................................ 134
LEVEL DIAGRAM ................................................. 136
ACCESSORIES ..................................................... 140
SPECIFICATIONS ................................................. 141
TS-480HX/480SAT
DISASSEMBLY FOR REPAIR
How to remove the torque changeover lever (G02-0898-04)
Cautions for mounting the main dial knob
(K21-1105-03)
1. Turn the lever section of the torque changeover lever to
the right. ( q )
2. Insert the tip of a flat-head screwdriver into the recessed
part of the torque changeover lever. ( w )
3. Lift the torque changeover lever using the tip of the flathead screwdriver. ( e )
Caution: Be careful not to damage the torque changeover
lever when lifting it.
4. Turn the lever section of the torque changeover lever to
the right, as in the position described in step 3. ( r )
5. Lift the torque changeover lever and remove it from the
panel ASSY.
Confirm that the lever section of the torque changeover
lever is in the fully turned left position (Torque OFF) before
mounting the main dial knob.
e
w
Cautions for replacing the torque changeover lever
Apply the dry-surf 2400 onto the front and rear surfaces
after replacing the torque changeover lever. (Do not apply the
dry surf to the lever section.)
q
r
Apply the dry-surf 2400
onto the front and rear
surfaces of the torque
changeover lever.
How to mount the torque changeover lever (G02-0898-04)
1. Insert the torque changeover lever into the mounting location so that the three tabs align with the torque
changeover slots. (Fig.1)
2. Turn the lever section of the torque changeover lever to
the left while pressing the surface of the lever as shown in
the Fig. 2, and mount it onto the panel ASSY.
2
Fig. 1
Fig. 2
TS-480HX/480SAT
CIRCUIT DESCRIPTION
Frequency Configuration
Figure. 1 shows the frequency configuration of this transceiver. All modes operate in a double conversion while transmitting. FM mode operates in a triple conversion and other
modes operate in a double conversion while receiving.
ANT
455kHz
73.095MHz
RX MIX
1st IF
LO1
2nd IF
73.125~
133.095MHz
FM
VCO1 VCO2 VCO3
CAR
TX
MIX
62.4MHz
AF OUT
CODEC
MIC IN
CAR
10.695MHz (Except FM)
10.24MHz (FM)
x2
PLL
LMX2360
DSP
FM IC
Except RX MIX
FM
LO2
TX MIX
3rd IF
TX/RX
MIX 10.695MHz
FM MOD
PLL REF
8.33~
8.47MHz
CF1
DDS DDS REF
AD9835
31.2MHz
DDS REF
DDS
AD9835
x2
fstd
X1
15.6MHz
Fig. 1 Frequency configuration
Reference Signal Generator
The reference frequency (fstd), which is used to control
the PLL frequency, oscillates at 15.6MHz in a crystal oscillation circuit (X1, Q1). This 15.6MHz signal passes through a
buffer amplifier (Q4) and is doubled in a multiplier (Q5) to generate a 31.2 MHz signal. The 31.2MHz signal is used as the
reference signal for the DDS (IC1) for the PLL reference signal of the first local oscillator (LO1) and the DDS (IC2) for a
carrier (CAR).
The SO-3 (TCXO unit) is configured as an option in this
transceiver, so that you can replace the crystal oscillation circuit (X1, Q1) with the SO-3. However, you must cut the R103
(0Ω) and R104 (0Ω) jumper wires to stop the operation of the
crystal oscillation circuit (X1, Q1) when using the SO-3.
LO1/LO2/CAR
■ LO1 (the 1st local oscillator)
A frequency between 8.33MHz and 8.47MHz is output
using the 31.2MHz signal as the reference signal in the DDS
(IC1). The output signal passes through a ceramic filter (CF1)
and enters into a PLL (IC3). This signal is divided into 1/8 (1/
R) in the PLL and becomes the comparison frequency fø for
the frequency between 1.041MHz and 1.058MHz.
The VCOs (Q451, Q452, Q456) of LO1 oscillate between
73.125MHz and 133.095MHz. The oscillation output of
these VCOs enter pin 6 of the PLL (IC3), then divides into 1/N
in the PLL. The comparison frequency fø is compared with
the frequency divided into 1/N by a phase comparator in the
PLL, then locks the frequency to use it as the output frequency of LO1.
In the DDS (IC1), the output frequency (8.33MHz to
8.47MHz) is swept with fDDS STEP [Hz]=10 x R/N when the
step is 10Hz or fDDS STEP [Hz]=1 x R/N when the step is 1Hz.
Therefore, LO1 covers the frequency range of 73.125MHz to
133.095MHz with 10Hz or 1Hz steps.
The PLL output generated by the above-mentioned
method is amplified at Q15 and passes through a band-pass
filter with a cutoff switching circuit, an attenuator, and a lowpass filter, and is then sent to the RF unit (X44-327) as LO1.
■ LO2 (the 2nd local oscillator)
The 15.6MHz (reference frequency) signal passes through
a buffer amplifier (Q4) and is doubled in a multiplier (Q5) to
generate a 31.2MHz signal. The resistance of the 31.2MHz
signal is distributed since it is used as the reference signal for
each DDS (IC1, IC2). The 31.2MHz signal is doubled in a
multipler (Q8, Q12) to generate a 62.4MHz signal.
The band-pass filter cuts the high harmonic of the
62.4MHz signal and the signal is sent to the RF unit (X44-327)
as LO2.
3
TS-480HX/480SAT
CIRCUIT DESCRIPTION
■ CAR (carrier)
The 10.695MHz used in the local oscillation and detection
is generated by the DDS (IC2). The output signal sent from
this DDS passes through a buffer amplifier (Q10) and a lowpass filter, and is then sent to each signal.
X1,Q1
15.6MHz
Q4
Q5
Buffer
x2
Q3
Q6
Q8
31.2MHz
Q12
LO2
62.4MHz
BPF
x2
Q10
TCXO
SO-3
CAR
10.695MHz
IC2
DDS
Buffer
LPF
Buffer
Q2
Q7
Q9
D1
Q11
CF1
Buffer
BPF
IC1
DDS
Buffer
FM MOD
8.33~8.47MHz
Q451
VCO1
Q14
Q455
IC3
PLL
Q15
Q452
VCO2
LPF
LPF
BPF
LPF
LO1
73.125~
133.095MHz
Q456
VCO3
Fig. 2 Reference signal generator, LO1/LO2/CAR
DDS AD9835BRU (IC1)
HF TX/RX
USB
LSB
CW
CW-R
Lo1
RX
TX
RX
TX
Filter offset 1
+1.5k
+1.5k
-1.5k
-1.5k
Filter offset 2
+0.71k
+0.71k
-0.71k
-0.71k
-
-
-
RIT
(∆ RIT)
-
(∆ RIT)
-
(∆ RIT)
-
(∆ RIT)
-
(∆ XIT)
-
(∆ XIT)
-
(∆ XIT)
-
+(IF S)
-
-(IF S)
-
+(IF S)
-
-(IF S)
-(CAR L)
+(CAR H)
+(CAR H)
-(CAR L)
XIT
IF Shift
CAR correction +(CAR H) +(CAR H)
HF TX/RX
Lo1
RX
TX
0
0
RIT
XIT
IF Shift
CAR correction
RX
TX
FSK-R
TX
RX
TX
0
0
-
-
-
-
(∆ RIT)
-
(∆ XIT)
-
(∆ XIT)
-
+(IF S)
-
-(CAR L)
-
-
TX
-(SHIFT/2) -(SHIFT/2)
AM
FM
RX
TX
RX
TX
RX
TX
-(SHIFT/2)
-(SHIFT/2)
0
0
0
0
-
-
-
-
-
-
-
-
-
-
(∆ RIT)
-
(∆ RIT)
-
(∆ RIT)
-
(∆ RIT)
-
(∆ RIT)
-
-
(∆ XIT)
-
(∆ XIT)
-
(∆ XIT)
-
(∆ XIT)
-
(∆ XIT)
-(IF S)
-
-(IF S)
-
+(IF S)
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
Filter offset 2 : DATA filter ON, The amount of IF shift when selecting Center “2210Hz”
(∆ RIT) : RIT frequency variable amount (-9.99~+9.99kHz)
(∆ XIT) : XIT frequency variable amount (-9.99~+9.99kHz)
(PITCH) : CW pitch frequency (400~1000Hz, Initial value 800Hz)
(SHIFT) : FSK shift width frequency (170Hz, 200Hz, 425Hz, 850Hz, Initial value:170Hz)
(MARK) : FSK mark frequency (H TONE : 2125Hz, L TONE : 1275Hz, Initial value : 2125Hz)
4
RX
+(1.5k-PITCH) +(1.5k-PITCH) -(1.5k-PITCH) -(1.5k-PITCH)
FSK
Filter offset 1
Filter offset 2
-(CAR L)
CWN-R
RX
CWN
Table 1
LO1 frequency shift data
TS-480HX/480SAT
CIRCUIT DESCRIPTION
DDS AD9835BRU (IC2)
CAR
USB
LSB
RX
TX
RX
CW
TX
CW-R
RX
TX
CWN
RX
RX
TX
Filter offset 1
+1.5k
+1.5k
-1.5k
-1.5k
-(1.5k-PITCH)
0
0
Filter offset 2
+0.71k
+0.71k
-0.71k
-0.71k
-
-
-
-
-
-
CW piitch
-
-
-
-
+(PIITCH)
-
-(PIITCH)
-
+(PIITCH)
-
FSK tone
-
-
-
-
-
-
-
-
-
-
+(IF S)
-
-(IF S)
IF Shift
CAR correction +(CAR H) +(CAR H) -(CAR L)
CAR
CWN-R
-
+(IF S)
-
-(IF S)
-
+(IF S)
-
-(CAR L)
+(CAR H)
+(CAR H)
-(CAR L)
-(CAR L)
-
-
FSK
TX
Filter offset 1
0
0
Filter offset 2
-
-
CW pitch
-(PIITCH)
-
-
FSK tone
-
-
-(MARK)
-(IF S)
-
-(IF S)
-
-
-
-
-
CAR correction
RX
FSK-R
RX
IF Shift
+(1.5k-PITCH) +(1.5k-PITCH) -(1.5k-PITCH)
TX
TX
-(SHIFT/2) -(SHIFT/2)
-
AM
FM
RX
TX
RX
TX
RX
TX
-(SHIFT/2)
-(SHIFT/2)
Stop
0
-455k
0
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-(MARK)
-
-
-
-
+(IF S)
-
-
-
-
-
-
-
-
-
-
-
-(MARK) +(MARK+SHIFT)
Filter offset 2 : DATA filter ON, The amount of IF shift when selecting Center “2210Hz”
(∆ RIT) : RIT frequency variable amount (-9.99~+9.99kHz)
(∆ XIT) : XIT frequency variable amount (-9.99~+9.99kHz)
(PITCH) : CW pitch frequency (400~1000Hz, Initial value 800Hz)
(SHIFT) : FSK shift width frequency (170Hz, 200Hz, 425Hz, 850Hz, Initial value:170Hz)
(MARK) : FSK mark frequency (H TONE : 2125Hz, L TONE : 1275Hz, Initial value : 2125Hz)
Table 2
CAR frequency shift data
Receiver Circuit
FM mode operates in a triple conversion: the first IF
(73.095MHz), the second IF (10.695MHz), and the third IF
(455kHz). All modes other than FM mode operate in a double
conversion: the first IF (73.095MHz), and the second IF
(10.695MHz).
■ From antenna to a preamplifier (Q153, 154)
There are two antenna terminals: ANT 1 and ANT 2. With
these antenna terminals, it is possible to select the terminal
to be used and store the selection for each band. A pigtail
wire is used in this transceiver to maintain the freedom of the
antenna wire when it is mounted in a car.
The receive signal sent from the antenna terminal enters
the ANT section (X45-366 C/3 : 200W transceiver, X45-365 C/
3 : 100W transceiver) of the final unit. The signal passes
through a surge trap, the antenna changeover relay, the antenna tuner changeover relay (only 100W transceiver), the
transmission/reception changeover relay, and an image filter,
and is then sent from CN503 to CN2 of the RF unit (X44-327)
though a co-axial cable.
The signal input into the RF unit passes through the attenuator circuit, the image filter, the surge absorption limiter,
and then enters the RF BPF. Although the default of the attenuator is 12dB, it can change to approximately 20dB by removing the CN4 jumper.
The RF BPF divides in the range as shown in table 3. The
transmit signal also passes through the RF BPF when transmitting.
The preamplifier (Q153, 154) receives the signal passed
through the RF BPF. This transceiver obtains necessary gain
and frequency characteristic by applying NFB (Negative
Feedback) to the source earthed circuit having two parallelconnected MOS FETs. Although the preamplifier was conventionally switched by switching between low-band and
high-band, this transceiver can obtain necessary characteristics for each band by switching the NFB amount of the
source at Q155.
You can turn the preamplifier ON/OFF by pressing the
[ATT/PRE] key.
Band
Filter range
BC
30kHz~1.705MHz
1.8MHz
1.705~2.5MHz
3.5MHz
2.5~4.1MHz
7MHz
4.1~7.5MHz
10MHz
7.5~10.5MHz
14MHz
10.5~14.5MHz
21MHz
14.5~21.5MHz
28MHz
21.5~30MHz
30~49MHz, 54~60MHz
50MHz
49~54MHz
Table 3
RF BPF
5
TS-480HX/480SAT
CIRCUIT DESCRIPTION
■ From receiving 1st mixer to the second IF frequency (10.695MHz)
the transmit signal by passing the narrow-band MCF. It also
reduces spurious components of the receive signal.
TP1 (CN152) and TP2 (CN252) adjust MCF. The signal
passed through the MCF is amplified at the first IF amplifier
(Q253) and converted to the second IF frequency (10.695
MHz) at the second receiving mixer (D256). The receiving
second mixer is the passive type mixer using diodes and the
transmit signal passes through it when performing transmission.
The second IF signal (10.695MHz) is sent from CN254 of
the RF unit (X44-327) to CN501 of the TX-RX unit (X57-663 A/
2) through a co-axial cable.
The output signal sent from the RF BPF passes through
the image filter and is converted to the first IF frequency
(73.095MHz) at the first receiving mixer (Q156, 157, 160,
161). The receiving first mixer has a circuit having quadruple
JFETs (Q156, 157, 160, 161). This same type of circuit is
used in high-class transceivers. Therefore, this transceiver
has the same or higher dynamic characteristics as high-class
transceivers.
Two MCF (XF151) with 2-poles are used in the next stage.
This transceiver reduces proximity spurious components of
ANT1
ANT2
Filter unit (C/3)
ANT section
RF unit
Except 200W
ATT
–12dB/
–20dB
RX
RF BPF
30kHz~
60MHz
TX
AT
TX
signal
Through
PRE AMP OFF
10.695MHz
RX 2nd IF
to TX-RX (A/2)
D256
RX 2nd Mixer
Q153,154
PRE AMP
Q253
1st IF AMP
Q156,157,160,161
RX 1st Mixer
MCF
XF151
73.095MHz
Q255
LO2 AMP
LO2
62.4MHz
AGC
Q159
LO1 AMP
LO1
73.125~133.095MHz
Fig. 3 From antenna to the second IF frequency (10.695MHz)
■ 10.695MHz IF filter circuit (Filter section (X57-663
B/2) of the TX-RX unit)
The TX-RX unit (X57-663 A/2) comprises the receiver circuit, the PLL circuit, the transmitter circuit (from AF to the
first IF: 10.695MHz), the AF DSP, and the control circuit.
The second IF signal (10.695 MHz) input into CN501 of the
TX-RX unit (X57-663 A/2) enters CN901 of the filter section
(X57-663 B/2). This unit has the 10.695MHz IF filter and the
IF amplifier. It is possible to remove the unit to mount a optional IF filter (two pieces) and TCXO (SO-3).
The second IF signal (10.695MHz) input from CN901 is
amplified at the second receiver IF amplifier (Q901). The second receiver IF amplifier operates as a gate of the noise
blanker. Q902 and Q901 turn OFF while blanking. Q901 amplifies the transmit signal.
The output signal sent from Q901 passes through the
10.695MHz IF filter and is amplified at the IF amplifier (Q971),
then returns to the TX-RX unit (X57-663 A/2) from CN971.
Table 4 shows the path of the 10.695MHz IF filter mode.
You can mount two IF filters from the following optional IF
filter types:
6
SSB NARROW: 1.8kHz, CW: 500Hz, and CW NARROW:
270Hz.
The option filter is automatically selected by the resistance, which is set in the option filter. Therefore, you do not
need to select the filter using menu or a switch.
Filter
Bandwidth
Through (R943, 945)
Through
FM
RX
Not used
TX
XF931
6kHz
AM
AM
XF932
2.4kHz
SSB/CW/FSK
SSB/CW/FSK
/AM NAR
/FM
Option filter 1
*1
*2
Not used
Option filter 2
*1
*2
Not used
*1: The bandwidth of the mounted IF filter is applied.
*2: The mode changes corresponding to the mounted IF filter.
The CW filter is available in SSB mode with the selection is in the
menu.
Table 4 IF filter selection
TS-480HX/480SAT
CIRCUIT DESCRIPTION
RF unit
TX-RX unit
(B/2)
Filter section
TX-RX unit (A/2)
D932
FM
D940 through
D932
D941
XF931
FM IF
10.695MHz
D934
AGC
Q901
IF AMP
AM 6kHz
XF932
D931
D936
Q971
IF AMP
RX OUT
10.695MHz
2nd IF
NB IN
Q508
10.695MHz
SSB/CW/FSK 2.4kHz
NB
Noise gate
blanker
D933
D935
Option
filter 1
Q902
SW
D933
D935
Option
filter 2
Fig. 4 10.695MHz IF filter circuit
■ From the receiver second IF to detection (TX-RX
unit (X57-663 A/2))
The path of the second IF signal (10.695MHz) input into
CN555 of the TX-RX unit (X57-663 A/2) is different between
FM mode and all other modes until the detection stage.
In modes other than FM mode, the second IF signal is
amplified at Q551 and Q554. The diode located at the second side of the loading side coil (L553) of Q551 is a PIN diode
(D551). With the current applied to the PIN diode, the receiving total gain, which is used to start the AGC operation, is
determined in modes other than FM mode. It is possible to
change the current with adjustment menu No.1 (AGC Ref.).
The transistor (Q561) connected to the source of Q554 is
used as a switch to mute the IF signals in modes other than
FM mode while transmitting.
The signal amplified at Q554 is detected at the mixer IC
(IC553) and becomes the AF signal in SSB/ CW/ FSK mode.
In AM mode, the signal amplified at Q554 passes through
Q556 and is detected at D555. Some DC bias is applied to
D555 to reduce distortion of small signals. The output signal
D552 sent from Q556 is rectified at D552 and the AGC voltage is generated by Q552.
In FM mode, the second IF signal enters into the FM IC
(IC551). The entered signal is converted to 455kHz. The signal is then amplified at the limiter circuit in the FM IC, where
it is detected.
Although the receive bandwidth in FM mode is decided by
the ceramic filter (CF551), the bandwidth of the filter does
not change in FM Narrow mode.
FM IF
10.695MHz
D940
RX OUT
10.695MHz
Q971
Q551
Q554
AGC D551 AGC
AMP RX ATT AMP
IC551
FM IC
FM
IC553
Mixer IC Q558
SSB/CW/FSK
IFGC
CAR
10.695MHz
Q561
Mute SW
Q556
IF AMP
D555
Q557
Buffer
AM
D552
TX-RX unit (B/2)
Filter section
AGC
TX-RX unit (A/2)
Q552
AGC AMP
Fig. 5 From the receiver second IF to detection
7
TS-480HX/480SAT
CIRCUIT DESCRIPTION
■ From detection to AF output
■ From the MIC terminal to modulation output
As for the AF signal detected in each mode, a necessary
mode for the signal is selected by the analog switch (IC733).
The AF signal is amplified at IC224 and IC218 and converted
to a digital signal by the CODEC (IC217), and is then sent to
the DSP (IC220).
In the DSP, the basic signal processing such as AF gain,
the interference elimination such as slope tune, and the noise
reduction such as NR are performed for the signal. The signal
is then converted to an analog signal again at the CODEC.
The analog signal is amplified at IC214, then re-amplified
at the AF amplifier (IC734) to drive the speaker.
To utilize the convenience of the “completely separated
panel type”, the internal speaker and the headphone terminal
is mounted in the panel and the external speaker terminal is
mounted in the transceiver.
To realize the priority of the received audio output (the
headphone (top priority), the external speaker (the second
priority), and the internal speaker (the third priority)), use the
headphone and the external speaker jack having a switch to
make each MCU (X54 IC3, X57 IC204) recognize the condition of the inserted plug and switch the relay set on the output of the AF amplifier (IC734) in order to select an appropriate path.
The frequency configuration of the transmitting part is
double superheterodyne: the transmitter first IF
(10.695MHz) and the transmitter second IF (73.095MHz).
The same type 16-bit DSP as the receiver circuit is used in
the audio signal processing stage.
The MIC terminal is mounted in the transceiver and a
modular jack is also employed. This is the fist time an HF
transceiver to has had a modular jack.
The AF signal input from the MIC terminal is amplified at
the microphone amplifier (IC221) and passes through the
analog switch (IC219), where it is amplified again at IC218.
The AF signal is converted to a digital signal by the CODEC
(IC217), and is then sent to the DSP (IC220).
In the DSP,. the MIC gain, the processor, and various filtering are performed for the signal and it is converted to an
analog signal by the CODEC. The analog signal is amplified at
IC214 and assigned to FM mode or a mode other than FM
mode by the DAC: IC212 (used as the electrical volume), and
is then sent to each modulation circuit.
IC733
Analog SW
IC218
IC224 (A/2)
SSB
CW
FSK
IC220
DSP
IC214
(A/2)
AM
TX-RX unit (A/2)
EXT. SP
Fig. 6 From detection to AF output
Transmitter Circuit
There are two types of transmission output: 200W (TS480HX) and 100W (TS-480SAT). The 100 W transceiver has
an internal antenna tuner.
With the presence of the internal antenna tuner, the final
section (A/3), the LPF section (B/3), and the ANT section (C/3)
of the final unit is different between the 200 W transceiver
and the 100W transceiver (200W transceiver: X45-366,
100W transceiver: X45-365). The same type of the TX-RX unit
(X57-663) and RF unit (X44-327) are used in both the 200W
transceiver and the 100W transceiver, even though there is a
small constant difference.
In addition, the same type of display unit (X54-341) is used
in both the 200W transceiver and the 100W transceiver.
8
Fig. 7
IC217
CODEC
IC218
(B/2)
IC212
DAC
IC214
(B/2)
FM MOD
SSB/AM/FSK
Balanced MOD
IC220
DSP
From the MIC terminal to modulation output
Signal Path Before/ After the CODEC
The signal path changes corresponding to the transmission/reception since the CODEC exchanges the signal with
the optional unit (VGS-1).
IC734
AF AMP
Panel
(INT. SP/Headphone)
IC221
MIC AMP
IC219
Analog
SW
TX-RX unit (A/2)
IC217
CODEC
FM
MIC
■ Functions relating to transmission
1) Modulation input path
The output signal sent from the analog switch (IC219) enters the CODEC, and is then sent to the DSP (IC220).
• The signal sent from the microphone is output from pin 11
to pin 10 of the analog switch.
• The signal sent from the data terminal (ANI) is output from
pin 1 to pin 2 of the analog switch.
• The message output signal (DRO) sent from the optional
unit (VGS-1) is output from pin 4 to pin 3 of the analog
switch.
2) Modulation output path
The AF signal processed at the DSP (IC220) enters the
CODEC (IC217) again and is amplified at IC214. The signal
amplified at IC214 passes through the following signal paths
in FM mode and SSB/ AM/ FSK mode. (The MIC gain is decided at the DSP, not DAC (IC212), in both modes.)
• FM mode
The signal enters pin 21 of the DAC, and is then sent from
pin 22 to the FM modulation circuit (FMOD).
• SSB/ AM/ FSK mode
The signal enters pin 24 of the DAC, and is then sent from
pin 23 to the balanced modulation circuit (SMOD).
TS-480HX/480SAT
CIRCUIT DESCRIPTION
3) Recording a message
2) Playback
The signal sent from the microphone is output from pin 11
to pin 10 of the analog switch (IC219), where it enters into
the CODEC (IC217). The signal sent from the CODEC enters
pin 13 of the DAC (IC212), and is then sent from pin 14 to the
optional unit (VGS-1) to be recorded.
The output signal (VOI) sent from the optional unit (VGS-1)
passes from pin 1 to pin 2 of the DAC. The signal passes
from pin 8 to pin 9 of the analog switch (IC219), and is then
mixed with the input signal of the AF amplifier (IC734). The
DAC (IC212) controls the volume.
■ Constant received audio recording function
1) Recording
■ Other functions
1) Playing a message (monitor)
A part of the received audio signal is sent from the CODEC
(IC217) to pin 13 of the DAC (IC212), and is then sent from pin
14 of the DAC to the optional unit (VGS-1) to be recorded. The
recording level is automatically compensated to become constant and you cannot randomly change the level.
The output signal (VOI) sent from the optional unit (VGS-1)
passes from pin 1 to pin 2 of the DAC. The signal passes
from pin 8 to pin 9 of the analog switch (IC219), and is then
mixed with the input signal of the AF amplifier (IC734). The
DAC (IC212) controls the volume.
2) Playing a pre-recorded voice message
The above-mentioned signal path is also used for playing a
pre-recorded voice message.
IC218 (A/2)
DET
MIC
IC219
Anolog SW
12
11
MIC
PKD 13
1
ANI
5
DRO
4
DRO
8
IC734
AF AMP
IC217
CODEC
IC212
DAC
10
2
3
6
VOO
AF OUT
9
IC220
DSP
21
22
24
23
16
15
13
14
DRM
1
VOI
FMOD
SMOD
ANO
VOS
2
VOAF
VOO
Option
VGS-1
TX-RX unit (A/2)
Fig. 8 Signal path before/after the CODEC
Modulation Circuit
The modulation signal processed at the DSP is sent to the
modulation circuit. The circuit receiving the modulation signal
is different between FM mode and SSB/ AM/ FSK mode.
1) SSB/ AM/ FSK mode
The modulation signal sent from the DAC (IC212) enters
the balanced modulator (IC621) after inverting the phase at
Q625. The 10.695MHz transmission signal sent from the balanced modulator is amplified at Q621 and is then sent to the
next stage.
• AM mode
The DC voltage is applied to the pin 1 of the balanced
modulator via D624. With the DC voltage, the AM carrier
is generated since the balanced modulator becomes unbalanced.
• FSK mode
In conventional FSK mode, the frequency of the carrier
was changed with the external keying signal. This trans-
ceiver generates the FSK signal by changing the single
tone (AF) generated at the DSP. The balanced modulator
performs the same operation as SSB mode.
• CW/FM mode
The necessary carrier wave is obtained by making the balanced modulator lose balance.
Q625
(1/2)
DC for
AM/FSK
SSB/AM/FSK
Mod. IN
TX-RX unit (A/2)
IC621
Balanced
Mod.
Differential
Q625 input
(2/2)
DSB OUT
10.695MHz
CAR
10.695MHz
Fig. 9 SSB/AM/FSK mode modulation circuit
9
TS-480HX/480SAT
CIRCUIT DESCRIPTION
2) FM mode
Although the circuit directly modulating the frequency of
the VCO and the crystal oscillator was conventionally used,
this transceiver uses a phase modulation circuit.
Set the variable capacity diode (D1) on the output of the
DDS (IC1) working as the source of the reference frequency
of the PLL circuit generating the first local oscillator (LO1).
Some DC fixed bias is applied to the variable capacity diode
(D1) in order to optimise the modulation sensitivity.
Although LO2 or the crystal oscillator (10.695MHz) is
modulated in the conventional transceiver, the first local oscillator (LO1) is modulated in this transceiver.
TX IF IN
10.695MHz
D938 D934
D941 D932
XF931
BW : 6kHz
AM
D936
XF932
BW : 2.4kHz
SSB/CW/FM/FSK
TX IF OUT
10.695MHz
D901 D903
Q901
D902
D905
TXB
Q903
R31
RXB
L7
R34
L11
L10
Ref. OSC
(31.2MHz)
IN
from Q7
TX-RX unit (A/2)
TX-RX unit (B/2)
Filter section
Fig. 11 From the modulation circuit to 10.695MHz
D1
FM Mod.
OUT
to Q9
FM Mod.
audio IN
Fig. 10 FM mode modulation circuit
■ From the modulation circuit to 10.695MHz
The transmission signal sent from the balanced modulator
(IC621) is sent from the filter section (X57-663 B/2) of the TXRX unit to the TXIN terminal (pin 8) of CN555. It is possible to
remove the unit to mount an optional IF filter and TCXO. You
can mount two optional IF filters. The IF transmit signal
passes through the XF931 (passband: 6kHz) in AM mode and
XF932 (passband: 2.4kHz) in modes other than AM mode.
Although various IF filters can be selected, corresponding
to the passband and mode when receiving, the IF filter is automatically selected by mode when transmitting. The transmit signal passes through the 10.695MHz IF filter, is amplified at the IF amplifier (Q901), and is then sent to the IFIN
terminal (pin 10) of CN554 of the TX-RX unit (A/2).
The IF amplifier (Q901) performs the gain varying operation with the ALC voltage while transmitting. The ALC voltage controls gate 2 of Q901 and the AGC voltage is applied to
gate 2 while receiving. The bias voltage transferred from
D905 is provided to the source of Q901 while transmitting.
Q903 turns ON while receiving and it discharges TXB voltage.
The transmit signal sent from the IF amplifier (Q901)
passes through D903 and D901. While D903 turns ON when
transmitting, D901 makes the attenuator operate by changing the impedance with the IFGC voltage which changes the
IF transmit signal. The level variance works as the TGC function controlling the transmit gain.
The 10.695MHz transmit IF signal returned from the IFIN
terminal (pin 10) of CN901 of the TX-RX unit (B/2) to the TXRX unit (A/2) is sent from CN501 of the TX-RX unit (A/2) to
CN254 of the RF unit (X44-327) through a co-axial cable.
■ From 10.695MHz to the drive output
The 10.695MHz transmit IF signal input into CN254 of the
RF unit (X44-327) is converted to the transmit frequency in
LO1 and LO2 and sent from CN1 to the final unit (A/3) as a
drive output.
The 10.695MHz transmit IF signal is converted to 73.095
MHz by LO2 (62.4MHz: 4 x 15.6MHz (the reference frequency) ) using the transmit mixer (D256). The D256 operates as a RX mixer while receiving mode.
The converted signal passes through D254 and is amplified at the IF amplifier (Q252). D254 can change the level of
the 73.095 MHz transmit IF signal by changing the impedance with the current corresponding to the PGC voltage. The
level variance compensates the gain of the transmit signal
when performing the power control.
The 73.095MHz transmit signal passes through the MCF
(XF151) and is converted to the desired transmit frequency
by LO1 in the final transmit mixer (IC251). This transceiver
can reduce proximity spurious components since the signal
passes through the MCF (passband: approximately 15kHz)
when transmitting.
The signal sent from the final transmit mixer passes
through the RF BPF and is amplified at the drive amplifier
(Q3) to drive the final stage, and is then sent from CN1 to the
final unit (A/3).
Many spurious components can be seen when the drive
output signal is analysed with the spectrum analyser. This
problem occurs when the transceiver is not properly adjusted
or the gain balance is not normal (when the input level to the
final transmit mixer (IC251) compensating the lack of gain of
the final stage is excessively high).
D256 PGC
Q252
TX mixer
RF unit
TX IF IN
10.695MHz
D254
Q255
MCF
73.095MHz
RF BPF
1.8~54MHz
Q3
Drive AMP
Fig. 12
XF151
LO1 IN
73.125~
133.095MHz
LO2 IN
62.4MHz
DRV OUT
1.8~54MHz
10
D931
IC251
TX mixer
From 10.695MHz to the drive output
TS-480HX/480SAT
CIRCUIT DESCRIPTION
■ From the drive output to antenna
The transmit signal sent from CN1 of the RF unit (X44-327)
to the final unit (A/3) is amplified to the predetermined power
in the final stage and passes through the LPF. It is then output from the antenna terminal. The 100W transceiver has an
internal relay type antenna tuner operating in all bands.
1) 100W transceiver
The transmit signal input into CN1 of the final unit (X45365 A/3) is amplified at the pre-drive amplifier (Q1, Q2) and
the drive amplifier (Q1,Q2) in the sub unit (X58-490) and the
final amplifier (Q4, Q5).
The signal is sent from CN11 to CN102 of the final unit
LPF section (X45-365 B/3) using the co-axial cable to eliminate high harmonic using the predetermined low pass filter,
and is then sent to the ANT section (X45-365 C/3) of the final
unit though a jumper wire. This ANT section has the forward
wave, reflected wave of detection circuit, the current for the
Q1
Q2
Pre drive AMP
Sub unit
Q1
Drive AMP
antenna tuner, the voltage detection circuit, the IN/
THROUGH changeover relay of the antenna tuner, transmission/ reception changeover relay, and the antenna
changeover relay, and obtains the transmit output from ANT1
or ANT2.
The antenna tuner has the LC tuning circuit in the final unit
(X45-365 A/3) and the detection/ control circuit in the ANT
section (X45-365 C/3) of the final unit. The operation is the
same as the conventional transceiver. The phase difference
signal of IC503 in the ANT part switches the condenser in the
input side of the final unit tuning circuit and the amplitude
difference signal of IC502 switches the condenser in the output side.
The SWR is decided by calculating the voltage of the forward wave and the reflected wave with the MCU (IC204).
The voltage of the forward wave and the reflected wave are
used for controlling the power, the power meter, and the
SWR protection.
Q4
Final AMP
TX LPF
1.8~50MHz
band
DRV IN
Q2
Drive AMP
Q5
Final AMP
Final unit (B/3)
LPF section
Final unit (A/3)
K502
AT IN
K502
K501
L506
Q507
AT through
ANT2 ANT1
VSR
VSF
L502
SWR
L505
RAT
(RF unit)
K503
IC510
Q506
IC503
Phase
ERROR
OUT
IC502
Amplitude
ERROR
OUT
IC509
D505
Final unit (C/3)
ANT section
D504
Fig. 13 From the drive output to antenna (100W)
2) 200W transceiver
The 200W transceiver has almost the same circuit configuration as the 100W transceiver to the drive stage.
To obtain 200W of electrical power, it has two 100W final
circuits and synthesizes electricity produced by the circuit. In
the actual circuit, the L802 splitter divides the drive output of
the sub unit (X58-490) into two final circuits. L818 synthesizes the produced outputs and L820 performs the impedance conversion to obtain approximately 50Ω. Although the
paths of the following steps are the same as the 100W type,
it does not have an antenna tuner.
Although the HF band of the transmit output is 200W,
100W is used for the 50MHz band by considering the heat
loss due to the downsizing.
We employed the method of synthesizing 100W outputs
to obtain 200W output. This method enables the transceiver
to operate at 13.8V supply voltage and the 200W operation of
the transceiver by using two 100W class regulated power
supplies.
This method is convenient for the fixed use of the transceiver since the existing regulated power supply can be used
by using two 100W class regulated power supplies to
achieve 200W operation. Although the voltage is applied
from two regulated power supplies to each final amplifier
(Q4, Q5, Q804, Q805), the amplifier may not work properly
when two supply voltages are significantly different and the
balance of the output synthesizing part is lost.
Therefore, this transceiver has a protection function that
monitors the voltages provided by the regulated power supplies and automatically stops transmission when the potential difference between the two voltages is more than 1V.
The transceiver has another protection function monitoring the heat of R816 of the final unit (X45-366 A/3) by the
thermistor (TH2) and detects the unbalance of the outputs
produced by each final amplifier, automatically reducing the
TX output power when the balance significantly degraded.
11
TS-480HX/480SAT
CIRCUIT DESCRIPTION
DRV IN
Q804
Q2
Drive AMP
L818,820
Q5
L802
Q1
Q2
Pre drive AMP
Final AMP
Q4
Sub unit
Q1
Drive AMP
Q805
Final unit (A/3)
ANT2 ANT1
K501
VSR
TX LPF
1.8~50MHz
band
Final unit (B/3)
LPF section
From the drive output to antenna (200W)
3) Common functions between 100W and 200W
■ ALC circuit and transmission power control
With the ideal design for cooling function, this transceiver
is the heavy-duty specification transceiver enabling the continuous transmission at the same full power as the fixed
transceiver while keeping its size small. However, you
should remember that in general, the heat caused by long
transmission time shortens the life of parts. Do not close the
ventilation ports located on the front and back of the transceiver.
The 200W transceiver has two fans and the 100W transceiver has one fan. The drive circuit of the fan is mounted on
the final unit (A/3) and controls the rotating speed of the fan
(OFF, slow, fast) corresponding to the generated heat.
This transceiver has a current protection circuit. The collector current of each final amplifier is converted to the potential difference of the resistance (10mΩ) inserted into a power
line and the potential difference is detected at IC801 of the
TX-RX unit (A/2). The ALC protection function activates with
the IC801 output when the potential difference exceeds the
predetermined value.
With this function, the transmission output decrease and
the excessive current does not flow even if the current in the
final part is increased for any reason. In addition, the transceiver has a temperature protection circuit and a SWR protection circuit.
Although a discreet circuit has conventionally been used
for the ALC circuit, this transceiver has a new type of circuit
comprising an operational amplifier. Even though the device
is different, the ALC circuit controls the ALC voltage using
the forward wave voltage (VSF) and keeps a constant output.
The voltage detected at the forward wave voltage and the
reflected wave voltage (VSR) detection circuit of the ANT
section of the final unit (C/3) is sent to the TX-RX unit (X57663 A/2). The forward wave voltage is divided into a suitable
voltage at R803 and R804, corresponding to the power type
and input into pin 6 of the operation amplifier (IC802), and is
then amplified. Part of the forward wave voltage is sent to
the meter amplifier comprising the operation amplifier
(IC732).
The ALC output provided by pin 7 of IC802 passes through
the diode for reverse current prevention (D811), and is then
input into pin 10 of IC802. The output provided by pin 8 of
IC802 passes through D816, and outputs it as the ALC voltage. The time constant of the ALC is determined by R822,
R828, and C812 connected to the line of pin 10 of IC802.
The ALC voltage is sent to the filter section (X57-663 B/2)
of the TX-RX unit and controls the gate 2 voltage, and then
changes the transmit gain. Part of the ALC voltage is sent to
pin 13 of IC802 and amplified at the operation amplifier in
IC802, and is then output from pin 14 of IC802. The output is
input the MCU (IC204) as the ALC meter voltage (ALM) via
the multiplexer (IC201).
The transmit output control is performed by changing the
comparison voltage (POC) of the operation amplifier (IC802).
The MCU (IC204) controls the comparison voltage and outputs the DC voltage from pin 6 of the DAC (IC681).
Q8
SW
14V
IC201 13
IC204
MultiMCU
118
plexer
86
12
TH1
TX-RX unit (A/2)
Final unit (A/3)
*
Q9
SW
*
FAN2*
FAN1
85
* : 200W only
Fig. 15 From the drive output to antenna
(100W and 200W common functions)
12
VSF
RAT
(RF unit)
K502
Final unit (C/3)
ANT section
Fig. 14
L502
SWR
TS-480HX/480SAT
CIRCUIT DESCRIPTION
The comparison voltage changes by changing the transmit
output on the panel. Although the transmit power control
was conventionally performed with the hardware control using the voltage of the supply line when the supply voltage
lowers, this transceiver uses the software control since the
MCU (IC204) always monitors the supply voltage. Therefore,
the transmit power gradually changes when the supply voltage is lower than the standard voltage (13.8V).
8C
R804
IC802
9
6
–
8 D816
D811
– 7
+
+
10 IC802
5
D818
CKY
ALC
OUT
R840
R803
VSF
R822
ALC time
constant
8C
C812 R828
D804 D802
POC
EXT ALC
D807
+
D808
D807
VSR
Protection
Current
ALC reference
Fig. 16 ALC circuit and transmission power control
Digital Control Circuit
■ Outline
The digital control circuit has a multi-chip configuration
around the main microcomputer (IC204) and it has DSP and
EEPROM, etc. (Refer to Fig. 17)
PC (RS-232C)
The DSP (IC220) operates at 1.8 V of the internal core voltage, 3.3V of the external I/O voltage, and 98.304MHz
(12.288MHz x 8) of the internal clock frequency. The firmware of the DSP is transferred from the main microcomputer
with the HPI bus when the transceiver is turned ON. The HPI
bus is also used in the command communication with the
main microcomputer. The buffer IC (IC222) is connected to
the data bus to enter the logic signal.
The sampling frequency of the CODEC (IC217) is 12kHz
and the clock is provided from the DSP. There are two channels for the analog signal input into the CODEC: DET IN and
PKD/ DRO/ MIC.
One of PKD/ DRO/ MIC is selected at the analog switch
(IC219), which is mounted in the previous stage and is controlled by the main microcomputer. There are two channels
for the analog signal output from the CODEC: AF OUT and
DRM/ ANO/ SMOD/ FMOD. The destination to be output is
selected from DRM/ ANO/ SMOD/ FMOD at the DAC
(IC212), which is mounted in the next stage and is controlled
by the main microcomputer.
External
AT
Logic signal
input buffer
IC222
Data bus
Panel
microcomputer
The main microcomputer operates at 3.3V of the supply
voltage and 22.1184MHz of the clock frequency. Three devices (panel microcomputer, PC serial port, and external AT)
for serial communication employing the UART function are
connected around the main microcomputer. The EEPROM
(IC202) is connected for backup purposes. The supply voltage monitoring circuit, including the reset circuit, is also connected.
■ Around the DSP
Q681,683
TX-RX unit (A/2)
■ Around the main microcomputer
EEPROM
IC202
Main
microcomputer
IC204
HPI bus
DSP
IC220
Reset circuit
Reduced voltage
detection circuit
PKD/DRO/MIC
DET IN
CODEC
IC217
DRM/ANO/SMOD/FMOD
AF OUT
Over voltage
detection circuit
Fig. 17 Digital control circuit
13
TS-480HX/480SAT
COMPONENTS DESCRIPTION
RF Unit (X44-327X-XX)
Ref No.
Use / Function
Ref No.
Use / Function
Operation / Condition / Compatibility
Q10: Hi when ATT is ON.
Q1
Switching
ATT changeover relay control
Q11: Hi when preamplifier is ON.
Q2
Switching
(OFF when ATT is ON)
D1
Surge absorption
Receiving RATB power supply control
D2~5
Limter
(ON during reception)
D51
Switching
Q3
Amplifier
Transmission drive output amplifier
Q4
Mute
Mutes reception path during transmis-
Q51~60
Switching
Q151
For ATT changeover relay
ON when receiving over 1.705MHz is
selected.
D52
Switching
BPF selection
D53
Switching
ON during transmission
Switching
ON when preamplifier is ON.
D54
Switching
ON when receiving over 1.705MHz is
Q152
Switching
ON when preamplifier is OFF.
Q153,154
Amplifier
Preamplifier
Q155
Switching
Gain changeover switch for preamplifier.
sion (ON during transmission)
ON when receiving over 21.5MHz
ON when receiving under 1.705MHz
is selected.
selected.
D55
Switching
ON when BPF of 1.705~2.5MHz is
selected.
D56
Switching
1/2: ON when BPF of 2.5~4.1MHz is
Q156,157
Mixer
Receiving first mixer
selected.
Q158
Switching
Preamplifier power supply control (ON
2/2: ON when BPF of 14.5~21.5MHz
when preamplifier is ON.)
is selected.
Q159
Amplifier
RX LO1 amplifier
Q160,161
Mixer
Receiving first mixer
selected.
Q251
Switching
Transmission IF mute control
2/2: ON when BPF of 30~49MHz and
(Mute when ON.)
54~60MHz are selected.
D57
Transmission IF amplifier
Q253
Amplifier
Receiving IF amplifier
selected.
Q255
Amplifier
LO2 amplifier
2/2: ON when BPF of 21.5~30MHz is
Q256
Switching
Gain correction between bands.
selected.
Switching
Q302
RX power supply
D59
Switching
1/2: ON when BPF of 7.5~10.5MHz is
Amplifier
Q301
D58
Switching
Q252
ON when receiving over 21.5MHz
Switching
1/2: ON when BPF of 4.1~7.5MHz is
1/2: ON when BPF of 10.5~14.5MHz
KYS signal control (ON when KEY is
is selected.
inserted.)
2/2: ON when BPF of 49~54 MHz is
selected.
control switch
D60
Switching
ON when receiving under 1.705MHz is
IC251
Mixer
Transmission mixer
selected.
IC301
Shift register
Q0: Hi when BPF of 7M band is selected.
D61
Switching
ON when BPF of 2.5~4.1MHz is selected.
Q1: Hi when BPF of 10M band is selected.
D62
Switching
ON when BPF of 4.1~7.5MHz is selected.
Q2: Hi when BPF of 14M band is selected.
D63
Switching
ON when BPF of 7.5~10.5MHz is selected.
Q3: Hi when BPF of 3.5M band is selected.
D64
Switching
ON when BPF of 10.5~14.5MHz is selected.
Q4: Hi when BPF of BC band is selected.
D65
Switching
ON when BPF of 14.5~21.5MHz is selected.
Q5: Hi when BPF of 21M band is selected.
D66
Switching
ON when BPF of 21.5~30MHz is selected.
Q6: Hi when BPF of 50M band is selected.
D67
Switching
Q7: Hi when BPF of 30~60M band is selected.
14
Operation / Condition / Compatibility
ON when BPF of 30~49MHz and
54~60MHz are selected.
Q8: Hi when BPF of 28M band is selected.
D68
Switching
ON when BPF of 49~54MHz is selected.
Q9: Hi when BPF of 1.8M band is selected.
D69
Switching
ON when BPF of 1.705~2.5MHz is selected.
TS-480HX/480SAT
COMPONENTS DESCRIPTION
Final Unit (X45-365X-XX) (B/3)
Ref No.
Use / Function
Operation / Condition / Compatibility
D151
Switching
ON when receiving preamplifier is OFF
Ref No.
Use / Function
Operation / Condition / Compatibility
D152
Switching
1/2: ON when receiving preamplifier is OFF
D100
LED
Backlight for KENWOOD logo
2/2: ON when receiving preamplifier is ON
D101
Surge absorption
Relay (K102)
D154
Switching
LO1 path transmission/reception changeover
D151
Surge absorption
Relay (K152)
D155
Switching
73.095 MHz IF path transmission/
D201
Surge absorption
Relay (K202)
reception changeover
D251
Surge absorption
Relay (K252)
On when receiving preamplifier is ON
D301
Surge absorption
Relay (K302)
D156
Switching
D251
Switching
ON during transmission
D351
Surge absorption
Relay (K352)
D252
Switching
IF path transmission/reception changeover
D401
Surge absorption
Relay (K402)
D253
Reverse current
AGC
D451
Surge absorption
Relay (K452)
prevention
Final Unit (X45-365X-XX) (C/3)
D254
Attenuator
PGC
D255
Switching
IF path transmission/reception changeover
Ref No.
Use / Function
Operation / Condition / Compatibility
D256
Mixer
RX 2nd/TX mixer
Q501~504
Driver
LPF changeover relay control
D301~304
Reverse current
PADDLE/KEY terminal
Q505
Driver
ANT/AT changeover relay control
Q506,507
Signal amplifier
AT phase signal amplifier
Q508
Driver
Transmission/reception changeover
IC501
Extended I/O
LPF control signal (Serial→Parallel)
IC502
Comparator
AT control amplitude signal discrimination
IC503
D flip-flop
AT control phase signal discrimination
IC509,510
Inverter
D501
High-frequency
prevention
Final Unit (X45-365X-XX) (A/3)
Operation / Condition / Compatibility
relay (K501) control
Ref No.
Use / Function
Q1,2
Pre-drive amplifier
Q3
Bias control
Q4,5
Final amplifier
Q6
Switching
Final power supply
Q7
Switching
Q6 gate bias control
Q8,9
Switching
FAN control switch
Q10
Switching
Power supply control for internal AT
Q11
Switching
Q10 gate bias control
D503
Surge absorption
Relay (K501)
D504
High-frequency
AT amplitude signal detection
Final stage bias current control
Reflected wave detection
rectification
D502
High-frequency
Forward wave detection
rectification
Q891
Switching
Relay (K891) control switch
IC1
AVR
B→8C
IC2
AVR
14V→5V
IC801
Extended I/O
AT coil control signal (Serial→Parallel)
IC802
Extended I/O
AT output C control signal (Serial→Parallel)
D506
Surge absorption
Relay (K502)
IC803
Extended I/O
AT input C control signal (Serial→Parallel)
D507
Surge absorption
Relay (K503)
IC804,805
Buffer
Convert 3V to 5V.
D508,509
Surge absorption
Lightning surge protection
D1,2
Temperature
Final stage bias current control
rectification
D505
High-frequency
AT phase signal detection
rectification
Final Unit (X45-366X-XX) (A/3)
compensation
D3
Surge absorption
Power supply surge protection
Ref No.
Use / Function
D4
Surge absorption
FAN
Q1,2
Pre-drive amplifier
D801~824
Surge absorption
Relay (K801~824)
Q3
Bias control
D891
Surge absorption
Relay (K891)
Q4,5
Final amplifier
Q6
Switching
Operation / Condition / Compatibility
Final (Q4, Q5) stage bias current control
B→14V
15
TS-480HX/480SAT
COMPONENTS DESCRIPTION
Ref No.
Use / Function
Operation / Condition / Compatibility
Ref No.
Use / Function
Operation / Condition / Compatibility
Q7
Switching
Q6 gate bias control
D501
High-frequency
Reflected wave detection
Q8,9
Switching
FAN control switch
Q803
Bias control
Final (Q804, Q805) stage bias current control
rectification
D502
Q804,805 Final amplifier
Q806
Switching
High-frequency
rectification
Final (Q804, Q805) stage bias voltage
D503
Surge absorption
generation
Transmission/reception changeover
Relay (K501)
Q807
Switching
Q806 gate bias control
D504
Surge absorption
ANT changeover relay (K502)
IC1
AVR
B→5V
D505,506
Surge absorption
Lightning surge protection
IC2
AVR
14S→8C
IC3
AVR
14V→8V (Final (Q804, Q805) stage bias
D2,3
Temperature
Display Unit (X54-3410-00)
power supply)
Ref No.
Use / Function
Operation / Condition / Compatibility
Final (Q4, Q5) stage bias current control
Q1~4
Switching
LCD dimmer control
Q5,6
Switching
Dimmer control for key illumination
5V power supply switch
compensation
D4
Surge absorption
FAN
Q7
Switching
D5
Surge absorption
Power supply surge protection
IC1,2
LCD driver
D6
Surge absorption
FAN
IC3
MCU
Panel microcomputer
D802,803
Temperature
Final (Q804, Q805) stage bias current
IC4,5
AND gate
Buffer
compensation
control
IC6
AVR
5V
D806
Surge absorption
Power supply surge protection
D1~4
LED
LCD backlight
D807
High-frequency
D5~9
Reverse current
Key matrix
rectification
prevention
Final Unit (X45-366X-XX) (B/3)
D10~13
LED
LCD backlight
D14
LED
Lights during transmission
Ref No.
Use / Function
Operation / Condition / Compatibility
D15
LED
Lights during reception
D100
LED
Backlight for KENWOOD logo
D16~36
LED
Backlight
D101
Surge absorption
Relay (K102)
D37
Reset circuit
D151
Surge absorption
Relay (K152)
D201
Surge absorption
Relay (K202)
D251
Surge absorption
Relay (K252)
Ref No.
Use / Function
Operation / Condition / Compatibility
D301
Surge absorption
Relay (K302)
Q1
Crystal oscillator
Crystal oscillation circuit (15.6MHz)
D351
Surge absorption
Relay (K352)
D401
Surge absorption
Relay (K402)
Q2
Amplifier
IC1-CLK input amplifier
D451
Surge absorption
Relay (K452)
Q3
Buffer
31.2MHz buffer
Q4
Buffer
15.6MHz buffer
Q5
Doubler
15.6MHz x 2
Final Unit (X45-366X-XX) (C/3)
TX-RX Unit (X57-663X-XX) (A/2)
circuit
Ref No.
Use / Function
Operation / Condition / Compatibility
Q6
Amplifier
IC2-CLK input amplifier
Q501~504
Driver
LPF changeover relay control
Q7
Buffer
DDS output buffer
Q505
Driver
ANT changeover relay control
Q8
Doubler
31.2MHz x 2
Q506
Driver
Transmission/reception changeover
Q9
Amplifier
Differential amplifier
relay control
Q10
Buffer
DDS output buffer
LPF control signal (Serial→Parallel)
Q11
Buffer
Impedance converter
IC501
16
Forward wave detection
Extended I/O
TS-480HX/480SAT
COMPONENTS DESCRIPTION
Ref No.
Use / Function
Operation / Condition / Compatibility
Ref No.
Use / Function
Operation / Condition / Compatibility
Q12
Doubler
31.2MHz x 2
Q557
Buffer
Output buffer for AM detection signal
Q13
Switching
LO1 filter cutoff changeover control
Q558
Amplifier
Output amplifier for SSB/CW detection signal
Q14
Amplifier
PLL-Fin amplifier
Q559
Switching
IF mute signal
Q15
Amplifier
LO1 amplifier
Q560
Switching
Option filter insertion loss correction switch
Q16
Switching
NFMT signal
Q561,562
Switching
IF amplifier mute switch
Q17
Ripple filter
Filter for VCO power supply
Q563
Switching
ON while receiving in FM mode
Q18
Switching
Loop filter time constant changeover switch
Q621
Amplifier
Output amplifier of SSB/CW modulator
Q19
Mute switch
Mutes FM modulation input
Q622
AVR
Power supply of SSB/CW modulator
Q131
Inverter
SQC
Q623
Buffer
CAR input buffer of SSB/CW modulator
Q132
Switching
RL output switch
Q624
AVR
Power supply of SSB/CW modulator
Q133
Amplifier
ANI/ANO signal amplifier, Amplitude limit
Q625
Amplifier
Modulation input of SSB/CW modulator
Q134
Switching
Relay (K131) control
Q681
Switching
CKY control
Q135
Switching
RL output switch control
Q682
Switching
TXB power supply generation switch
Q136
Inverter
PKS signal
Q683
Switching
CKY control
Q137
Inverter
RTK signal
Q684,685
Switching
RXB power supply generation switch
Q138
Inverter
SS signal
Q686
Switching
AGC voltage charge switch control
Q201,202 AVR
Panel power supply
Q731
Switching
For meter
Q203
Switching
IC203 (RS-232C) power supply control
Q732
Switching
FMB
Q204
Switching
Power supply voltage protection
Q733
Switching
AMB/SCB
Q205
Inverter
Q734
Switching
AF mute switch
Q207
Switching
5C power supply switch
Q735
Ripple filter
For audio amplifier power supply
Q451
VCO1
Oscillation FET
Q737
Switching
Audio output relay changeover control
Q452
VCO2
Oscillation FET
Q803
Switching
ALC time constant changeover switch
Q453,454 Switching
VCO select switch
Q805
Switching
AGC voltage charge switch control
Q455
Amplifier
VCO output amplifier
Q806
Over drive
Q456
VCO3
Oscillation FET
Q457
Switching
VCO select switch
Q807
Switching
Q501
Amplifier
NB circuit input
IC1
DDS
LO1-PLL reference signal is generated
Q502
Differential
NB IF amplifier
IC2
DDS
CAR generation
IC3
PLL
LO1 control
IC201
Multiplexer
Input signal changeover for entering it
amplifier
protection
Q503
Amplifier
NB AGC control amplifier
Q504
Amplifier
NB IF amplifier
Q505
Switching
Audio mute signal is generated
IC202
EEPROM
Q506
Buffer
NB IF
IC203
Level converter
RS-232C level and 5 V conversion
Q507
Switching
Audio mute signal is generated
IC204
MCU
Main microcomputer
Q508
Buffer
NB input buffer
IC205
Buffer IC
Voltage conversion: 3V→5V
Q551
AGC amplifier
AGC amplifier for receiving second IF
IC207
Buffer IC
Voltage conversion: 5V→3V
Q552
AGC amplifier
AGC voltage control
IC208
Buffer IC
Voltage conversion: 3V→5V
Q553
Switching
AGC-OFF switch
IC209
Buffer IC
Voltage conversion: 5V→3V
Q554
AGC amplifier
AGC amplifier for receiving second IF
IC210,211
Reset IC
Q556
Amplifier
IF amplifier for AM/AGC
IC212
A/D
into the A/D port of MCU (IC204)
Electrical volume, Control signal is generated
17
TS-480HX/480SAT
COMPONENTS DESCRIPTION
Ref No.
Use / Function
Operation / Condition / Compatibility
Ref No.
IC213
3.3V AVR
IC214
Filter amplifier
CODEC output signal
selected.
IC215
3.3V AVR
DSP power supply
Q5: Hi when AGC is slow.
IC216
1.8V AVR
DSP power supply
Q6: Hi when AGC is OFF.
IC217
CODEC
IC218
Anti-aliasing filter
IC219
Analog switch
Q9: Low when option filter 1 is selected.
IC220
DSP
Q10: Low when option filter 2 is selected.
IC221
MIC amplifier
Q11: Low when receiving in FM mode.
IC222
Buffer
IC732
OP amplifier
Buffer/ amplifier for meter
IC223
Inverter
IC733
Analog switch
Reception detection output changeover
IC224
Amplifier
RX signal amplifier, Reference voltage
IC734
AF AMP
generation
IC801
OP amplifier
Power supply voltage protection
Operation / Condition / Compatibility
Voltage conversion: 3V→5V
IC802
OP amplifier
ALC protection
D1
Variable
For FM phase modulation
Q4: Hi when the 1.8kHz option filter is
Q7: Low when the 6kHz filter is selected.
CODEC input signal
Q8: Low when the 2.4kHz filter is selected.
IC225,226
Buffer IC
IC227
Buffer
IC551
FM IC
FM detection
IC552
Analog switch
AGC/ALC voltage changeover
D2,3
Switching
IC553
Mixer IC
SSB/ CW demodulator
D4
Reverse current
IC554
Amplifier
FM S-meter voltage amplifier
IC621
Mixer IC
SSB/ CW transmission modulator
D131
Limiter
SQC over input protection
IC681
D/A
Ao1: NBL/MOB
D132
Limiter
ANI amplitude limit
Ao2: CAR-LEVEL
D133
Limiter
SS over input protection
Ao3: IFGC
D134
Limiter
ANI amplitude limit
Ao4: AGC-REF
D135
Limiter
RTK over input protection
Ao5: PGC
D136
Surge absorption
Relay (K131)
Ao6: POC
D137
Limiter
Over input protection
Ao7: VREF
D138
Reverse current
capacitance diode
Analog switch
LO1 filter cutoff changeover
prevention
Vo8: PRO
IC682
prevention
AGC time constant changeover,
D139
Limiter
Over input protection
S-meter changeover
D202
Poly-switch
Current limit
Over input protection
IC683
OP amplifier
Buffer for S-meter
D203,204
Limiter
IC684
Analog switch
NBL changeover switch
D205
Reverse current
IC685
Analog switch
AGC voltage charge
IC695
5V AVR
IC731
Shift register
prevention
D206
Q0: Low when SSB/CW/FSK mode is
10V Zener
Panel power supply reference voltage
diode
generation
Over input protection
selected.
D207
Limiter
Q1: Low when AM mode is selected.
D208
Reverse current
Q2: Low when FM mode is selected.
Q3: Hi when the 270Hz option filter is
prevention
D210
selected.
Reverse current
prevention
D211
18
Use / Function
Limiter
Over input protection
TS-480HX/480SAT
COMPONENTS DESCRIPTION
Ref No.
Use / Function
Operation / Condition / Compatibility
Ref No.
Use / Function
D212
18V Zener diode
Voltage shift
D810
Voltage shift
D213
Reverse current
D811~813
Reverse current
prevention
D351~354
Limiter
D355,356
Reverse current
prevention
Over input protection
D358,359
Poly-switch
D816,817
Reverse current
prevention
prevention
D357
Operation / Condition / Compatibility
D818,819
Current limit
Temperature
compensation
Reverse current
TX-RX Unit (X57-663X-XX) (B/2)
prevention
D360
Poly-switch
Current limit
Ref No.
Use / Function
Operation / Condition / Compatibility
D451,452
Varicap
VCO oscillation frequency variance
Q901
Amplifier
10.695MHz IF amplifier (AGC/ALC amplifier)
D453
Switching
ON when VCO1 is selected.
Q902
Switching
Q901 mute switch (Mute when ON)
D454
Switching
ON when VCO2 is selected.
Q903
Switching
TXB discharge switch (ON during
D455
Varicap
VCO oscillation frequency variance
D456
Switching
ON when VCO3 is selected.
Q971
Amplifier
10.695 MHz IF amplifier for receiving
D501
Rectification
NB voltage generation
D901
Attenuator
IFGC voltage control
D551
PIN diode
IF gain control (IFGC)
D902
Switching
ON during transmission
D552
Rectification
AGC control voltage generation
D903
Attenuator
IFGC voltage control
D555
Rectification
AM detection
D904
Switching
ON during reception
D557~559
Reverse current
D905
Reverse current
transmission)
prevention
D621,622
D623
Voltage shift
prevention
Reference voltage generation of TX
D906
Switching
ON during reception
modulator power supply
D931
Switching
ON when SSB mode is selected.
D932
Switching
1/2: ON when FM mode is selected.
Temperature
compensation
D624
D625
D681~683
D733~735
2/2: ON when AM mode is selected.
Reverse current
D933
Switching
ON when option filter is selected.
prevention
D934
Switching
ON when AM mode is selected.
Temperature
D935
Switching
ON when option filter is selected.
compensation
D936
Switching
ON when SSB mode is selected.
Reverse current
D937
Switching
ON when option filter is selected.
prevention
D938
Switching
ON during transmission.
Reverse current
D939
Switching
ON when option filter is selected.
prevention
D940
Switching
ON when FM mode is selected.
D941
Switching
ON when AM mode is selected.
D944,945
Limiter
D736
Surge absorption
D801
5.1V Zener diode
D802
Reverse current
Relay (K731)
Sub Unit (X58-4900-XX)
prevention
D804
Voltage shift
Ref No.
Use / Function
Operation / Condition / Compatibility
D805~808
Reverse current
Q1,2
Amplifier
Drive amplifier
prevention
D1,2
Voltage shift
D809
Limiter
External ALC voltage
Over voltage protection
19
TS-480HX/480SAT
SEMICONDUCTOR DATA
Main Microcomputer : HD64F2338VFC25 (TX-RX Unit IC204)
Pin No.
Name
I/O
Function
Pin No.
1
DRO
O
CODEC input (VGS-1 playback) change-
2
PKD
O
CODEC input (PKD) changeover instruc-
over instruction
tion
4
WAIT
5~8
HA0~HA3
9
Vss1
-
10~13
NC
-
14~17
TYP0~TYP3
I
Market code detection
18
Vss2
-
GND
19~22
TYP4~TYP7
I
Market code detection
23
DASH
I
Electronic key dash signal
L : Dash ON
24
DOT
I
Electronic key dot signal
L : Dot ON
25
KYS
I
BKC
I
Reduced voltage detection interrupt
43
SPS
I
External speaker detection signal input
H→L : Interrupt
H : When Speaker jack is connected
Power supply voltage 3.3V
44
DADT
I
Bus cycle wait state request
45
DACK
O
D/A (X57 IC212) exclusive clock
O
Address bus
46
IEN3
O
D/A (X57 IC212) exclusive enable
GND
47
Vss4
-
GND
48
LNA1
O
LINEA control signal 1 (relay)
49
LNA2
O
LINEA control signal 2 (RL)
I
O
D/A (X57 IC212) exclusive data
H : Relay operation selection
H : RL output selection
50
PKP
O
Cross-band repeater operation instruction
Key jack connection detection
51
SQC
O
Squelch signal
H : Key jack connection
52~55
HD0~HD3
O
Data bus
Key down signal
56
Vss5
-
GND
L : Key down
L : Cross-band selection
H : Open, L : Close
27
Vss3
-
GND
57~60
HD4~HD7
O
Data bus
28
TXC
O
Transmission power supply instruction
61
Vcc3
I
Power supply voltage 3.3V
H : Transmission, L : Reception
62
TXD0
O
Panel microcomputer communication
29
CKY
O
Transmission power output instruction
H : Transmission output
63
TXD1
O
The data output to PC/IF
30
ABK
O
ABK signal
64
RXD0
I
Panel microcomputer communication
31
BEEP
O
Beep pattern instruction
32
DRES
O
DSP reset output
33
MIC
O
CODEC input (MIC) changeover instruction
H : AF blanking
data output
H : Beep output
L→H : Reset
data input
65
RXD1
I
Data input from PC/IF
66
PHSW
O
External / internal speaker changeover
H : When MIC input is selected
34
VOS
O
Voice output changeover instruction
L : Internal speaker
67
AMU
O
H : Voice output
35
SSR
I
PTT transmission instruction
36
PKSR
I
Packet transmission/
68
TCS
O
69
STS
O
38
STPC
STPA
I
I
RS-232 IC start instruction
H : RS-232 power on
70
RTS1
O
Cross-band H : Reception, L : Transmission
37
AT tuning status instruction
H : During AT tuning
Cross-band transmission instruction
Normal H : Transmission, L : Reception
AF mute signal (Power ON/OFF)
H : AF blanking
H : PTT transmission, L : Reception
The UART operation instruction output
to PC/IF
Interrupt for returning from sleep mode
71
Vss6
-
GND
(PC)
72
CTS1
I
The UART operation instruction input
73
BUSY
I
L→H : Interrupt
Interrupt for returning from sleep mode
(Panal)
20
Function
42
H : When PKD input is selected
Vcc1
KEY
I/O
H : VGS-1 playback
3
26
I
Name
H→L : Interrupt
39
Vcc2
I
Power supply voltage 3.3V
40
TYPX
I
Function detection 1
41
BOVR
I
Over voltage detection interrupt
H→L : Interrupt
from PC/IF
VGS-1 busy status detection
H : Busy
VGS-1 connection detection (Power ON)
74
PLAY
I
75
NC
I
VGS-1 playback detection
L →H : Playback start
TS-480HX/480SAT
SEMICONDUCTOR DATA
Pin No.
Name
I/O
Function
76
DRE
O
77
NC
I/O
78
RST
O
VGS-1 reset signal
79
REN
O
RF serial parallel enable
80
PRGS
O
Pin No.
VGS-1 enable
Name
I/O
Function
110
TYPY
I
Function detection 2
111
AMD
I
Amplitude comparison detection instruction
112
PHD
I
Phase comparison detection instruction
113
AVcc
I
Power supply voltage 3.3V
Pre-amplifier gain changeover instruction
114
Vref
I
Power supply voltage 3.3V
H : High band, L : Low band
115
VDT1
I
Power supply voltage detection 1
L→H : Reset
81
ATEN
O
AT enable
116
VDT2
I
Power supply voltage detection 2
82
PSC1
O
Power supply relay control 1
117
VSFM
I
Forward wave voltage
H : Power ON
118
VSRM
I
Reflected wave voltage
I
A/D input (THP1/THP2/FIL1/FIL2)
83
PSC2
O
Power supply relay control 2
119
AXC
H : Power ON
120
AYC
I
A/D input (MUP/MDN/ALC/UNB)
84
FEN1
O
Final serial parallel enable 1 (AT control)
121
SM
I
S-meter voltage
85
FANL
O
Fan low-speed rotation instruction
122
SQL
I
Squelch voltage
L : Fan stop
123
Avss
-
GND
Fan high-speed rotation instruction
124
Vss8
-
GND
H : High-speed rotation
125
ADC1
O
Analog switch control signal
126
ADC2
O
Analog switch control signal
127
EEN
O
EEPROM enable
86
FANH
O
87
NC
O
88
REST
I
Hard reset input
89
NMI
I
H : Normal
90
STBY
I
Hardware standby terminal
91
Vcc4
I
92
XTL
93
94
128
EDA
I
EEPROM data input
129
ECK
O
EEPROM clock
Power supply voltage 3.3V
130
ESI
O
EEPROM data output
I
Crystal oscillator (22.1184MHz)
131
RBK
O
RBK signal
EXTL
I
Crystal oscillator (22.1184MHz)
132
DENB
O
DDS enable 2
Vss7
-
GND
133
DENA
O
DDS enable 1
95
NC
I
134
PENA
O
PLL enable
96
Vcc5
I
Power supply voltage 3.3V
135
MD0
I
Operation mode setting terminal 0
97
FWE
I
Flash write enable
136
MD1
I
H : Normal
L : Normal, H : During writing
98
NC
O
99
HRD
O
External address space lead terminal
100
HWR
O
101
IEN2
102
H : RF blanking
L : Normal, H : During writing
Operation mode setting terminal 1
H : Normal/During writing
137
MD2
I
Operation mode setting terminal 2
External space write strobe (D8~D15)
138
PDCK
O
PLL common clock
O
IF serial parallel enable 2 (For DAC)
139
PDDA
O
PLL common data
IEN1
O
IF serial parallel enable 1
140
VCO1
O
VCO1 changeover instruction
103
DATA
O
Common data
104
CLK
O
Common clock
141
VCO2
O
VCO2 changeover instruction
105
TTO
O
External AT control
106
TSI
I
External AT control
107
FEN2
O
Final serial parallel enable
108
TSO
O
109
TTI
I
H : Normal
H : Normal, L : During writing
H : VCO1 selection
H : VCO2 selection
142
VCO3
O
VCO3 changeover instruction
External AT control
143
HCS
O
DSP control chip select
External AT control
144
UL
I
Unlock signal
H : VCO3 selection
21
TS-480HX/480SAT
SEMICONDUCTOR DATA
Panel Microcomputer : 30622M8A-7N0GP (Display Unit IC3)
Pin No.
I/O
Function
Pin No.
Name
I/O
Function
1
P94
O
Key illumination LED control signal
35
P61
-
Not used
2~5
P93~P90
O
Dimmer output 3~0
36
CTS0
-
Not used
6
BYTE
I
Single chip mode selection (Vss connection)
37~44
P57~P50
-
Not used
7
CNVSS
I
Single chip mode selection (Vss connection)
45~50
P47~P42
-
Not used
8,9
P87, P86
-
Not used
51
P41
O
LCD segment display off control output
10
RESET
I
For Reset
52
P40
-
Not used
11
XOUT
O
System clock output
53
P37
O
LCD clock output
12
VSS
-
GND
54
P36
O
LCD data output
13
XIN
I
System clock input
55
P35
O
LCD driver 0 chip select output
14
VCC
-
Power supply input
56
P34
O
LCD driver 1 chip select output
15
P85
-
Not used
57~59
P33~P31
-
Not used
16
INT2
-
Not used
60
VCC
-
Power supply input
17
INT1
I
Interrupt from a serial reception port
61
P30
-
Not used
18
INT0
I
MULTI encoder pulse 1 input
62
VSS
-
GND
19
TA4IN
I
Main encoder
63~65
P27~P25
-
Not used
20
TA4OUT
I
Main encoder
66~70
P24~P20
O
Key scan output bit 4~0
21
TA3IN
I
RIT encoder
71~78
P17~P10
I
Key scan input bit 7~0
22
TA3OUT
I
RIT encoder
79~86
P07~P00
-
Not used
23
P75
I
MULTI/CH Encoder input
87
P107
-
Not used
24
P74
-
Not used
88,89
AN6, AN5
-
Not used
25
P73
I
Speaker jack insertion detection
90
AN4
I
Power key input
26
P72
-
Not used
91
AN3
-
Not used
27
P71
O
Busy LED control signal
92
AN2
I
SQ/RF VOL(A/D)
28
P70
O
TX LED control signal
93
AN1
I
AF VOL(A/D)
29~31
P67~P65
-
Not used
94
AVSS
-
Analog power supply input (GND)
32
CTS0
-
Not used
95
AN0
I
IF-SHIFT VOL(A/D)
33
TXD0
O
The serial port for connection with the
96
VREF
-
A/D reference voltage input
main unit
97
AVCC
-
Analog power supply input (5C)
The serial port for connection with the
98,99
P97, P96
-
Not used
main unit
100
P95
O
Key illumination LED control signal
34
22
Name
RXD0
I
L : Reset
L:ON
TS-480HX/480SAT
SEMICONDUCTOR DATA
Extended I/O Port
■ RF unit
Pin No. Port name
Pin name
Function
Active level
Condition
IC301 : BU2099FV (Shift register)
5
LCK
REN
6
Q0
BPF4
4.10~7.50MHz BPF
L
When BPF is selected
7
Q1
BPF5
7.50~10.5MHz BPF
L
When BPF is selected
8
Q2
BPF6
10.5~14.5MHz BPF
L
When BPF is selected
9
Q3
BPF3
2.50~4.10MHz BPF
L
When BPF is selected
10
Q4
BPF1
30k~1.705MHz BPF
L
When BPF is selected
11
Q5
BPF7
14.5~21.5MHz BPF
L
When BPF is selected
12
Q6
BPF10
49.0~54.0MHz BPF
L
When BPF is selected
13
Q7
BPF9
30~49, 54~60MHz BPF
L
When BPF is selected
14
Q8
BPF8
21.5~30.0MHz BPF
L
When BPF is selected
15
Q9
BPF2
1.705~2.5MHz BPF
L
When BPF is selected
16
Q10
ATT
RX-ATT ON/OFF
L
When ATT is ON
17
Q11
PRE
Pre-AMP ON/OFF
H
When Pre-AMP is ON
■ Final unit
Pin No. Port name
Pin name
Function
Active level
Condition
IC501 : BU2099FV (Extended I/O), Enable : FEN2
6
Q0
NC
7
Q1
NC
8
Q2
ANT’
HF ANT2 switching relay
H
L : ANT1, H : ANT2
9
Q3
ATS’
In/Through switching relay
L
L : In, H : Through
10
Q4
50M’
50M LPF relay
L
30.0 ≤ f ≤ 60.0 (MHz)
11
Q5
10M’
10M LPF relay
L
7.50 ≤ f < 10.50 (MHz)
12
Q6
4M’
3.5M LPF relay
L
2.50 ≤ f < 4.70 (MHz)
13
Q7
14M’
14M LPF relay
L
10.50 ≤ f < 14.50 (MHz)
14
Q8
28M’
24 / 28M LPF relay
L
21.50 ≤ f < 30.0 (MHz)
15
Q9
7M’
5 / 7M LPF relay
L
4.70 ≤ f < 7.50 (MHz)
16
Q10
2M’
1.8M LPF relay
L
f < 2.50 (MHz)
17
Q11
21M’
18 / 21M LPF relay
L
14.50 ≤ f < 21.50 (MHz)
IC801 : UPD6345GS (Extended I/O), Enable : FEN1, 100W only
12
Q1
L (1)
50M coil
L
30.0 ≤ f ≤ 60.0 (MHz)
11
Q2
L (2)
28M coil
L
25.50 ≤ f < 30.0 (MHz)
10
Q3
L (3)
24.9M coil
L
21.50 ≤ f < 25.50 (MHz)
9
Q4
L (4)
18, 21M coil
L
14.50 ≤ f < 21.50 (MHz), 30.0 ≤ f ≤ 60.0 (MHz)
8
Q5
L (5)
14M coil
L
10.50 ≤ f < 14.50 (MHz)
7
Q6
L (6)
10M coil
L
7.50 ≤ f < 10.50 (MHz)
6
Q7
L (7)
7M coil
L
6.90 ≤ f < 7.50 (MHz), 30 ≤ f < 60.0 (MHz)
5
Q8
L (8)
3.5M coil
L
2.50 ≤ f < 4.70 (MHz), 18.50 ≤ f < 60.0 (MHz)
23
TS-480HX/480SAT
SEMICONDUCTOR DATA
Pin No. Port name
Pin name
Function
Active level
Condition
IC803 : UPD6345GS (Extended I/O), Enable : FEN1, 100W only
12
Q1
CI (1)
25p capacitor switching
L
Phase error correction C1 On : Active, Off : Inactive
11
Q2
CI (2)
5p capacitor switching
L
Phase error correction C2 On : Active, Off : Inactive
10
Q3
CI (3)
10p capacitor switching
L
Phase error correction C3 On : Active, Off : Inactive
9
Q4
CI (4)
18p capacitor switching
L
Phase error correction C4 On : Active, Off : Inactive
8
Q5
CI (5)
39p capacitor switching
L
Phase error correction C5 On : Active, Off : Inactive
7
Q6
CI (6)
75p capacitor switching
L
Phase error correction C6 On : Active, Off : Inactive
6
Q7
CI (7)
150p capacitor switching
L
Phase error correction C7 On : Active, Off : Inactive
5
Q8
CI (8)
300p capacitor switching
L
Phase error correction C8 On : Active, Off : Inactive
IC802 : UPD6345GS (Extended I/O), Enable : FEN1, 100W only
12
Q1
CO(1)
25p capacitor switching
L
Amplitude error correction C1 On : Active, Off : Inactive
11
Q2
CO(2)
5p capacitor switching
L
Amplitude error correction C2 On : Active, Off : Inactive
10
Q3
CO(3)
10p capacitor switching
L
Amplitude error correction C3 On : Active, Off : Inactive
9
Q4
CO(4)
18p capacitor switching
L
Amplitude error correction C4 On : Active, Off : Inactive
8
Q5
CO(5)
39p capacitor switching
L
Amplitude error correction C5 On : Active, Off : Inactive
7
Q6
CO(6)
75p capacitor switching
L
Amplitude error correction C6 On : Active, Off : Inactive
6
Q7
CO(7)
150p capacitor switching
L
Amplitude error correction C7 On : Active, Off : Inactive
5
Q8
CO(8)
300p capacitor switching
L
Amplitude error correction C8 On : Active, Off : Inactive
Active level
Condition
■ TX-RX unit
Pin No. Port name
Pin name
Function
IC731 : BU2099FV (Shift register)
5
LCK
IEN1
6
Q0
SCC
7
Q1
AMC
AM power supply
L
When AM mode is selected
8
Q2
FMC
FM power supply
L
When FM mode is selected
9
Q3
270H
270Hz option filter gain correction
L
When 270Hz filter is selected
10
Q4
1.8k
1.8kHz option filter gain correction
H
When 1.8kHz filter is selected
SSB/CW/FSK power supply
When SSB,CW and FSK modes are selected
11
Q5
AGCSLOW
AGC-SLOW SW
H
When AGC SLOW is selected
12
Q6
AGCOFF
AGC-OFF SW
H
When AGC OFF is selected
13
Q7
FILT1
6kHz AM filter selection
L
When 6kHz filter is selected
14
Q8
FILT2
2.4kHz SSB filter selection
L
When 2.4kHz filter is selected
15
Q9
FILT3
Option filter 1
L
When option filter 1 is selected
16
Q10
FILT4
Option filter 2
L
When option filter 2 is selected
17
Q11
FILT5
Filter through
L
When FM mode is selected
IC681 : M62353AGP (D/A)
12
LD
IEN2
15
Ao1
NBL/MOB
NB threshold voltage output,
2
Ao2
CAR LEVEL
CAR adjustment voltage output
3
Ao3
IFGC
IF-Gain control voltage output
4
Ao4
AGC REF
AGC reference voltage output
5
Ao5
PGC
RF Gain control voltage output
6
Ao6
POC
Power control voltage output
FM transmission modulation bias output
24
L
7
Ao7
VREF
ALC reference voltage
10
Ao8
PRO
Protection control reference voltage
TS-480HX/480SAT
SEMICONDUCTOR DATA
Pin No. Port name
Pin name
Function
Active level
Condition
IC212 : M62364FP (A/D)
6
LD
IEN3
1
VIN1
VOI
VGS-1 playback signal input
Uses only to playback VGS-1.
2
VOUT1
VOO
VGS-1 playback signal output
Uses only to playback VGS-1.
3
VOUT2
NC
4
VIN2
NC
9
VIN3
GND
10
VOUT3
NC
GND
11
VOUT4
FMT
FM transmission signal
12
VIN4
GND
GND
During transmission in FM mode : 00
13
VIN5
14
VOUT5
DRM
VGS-1 input signal output
CODEC output signal input
15
VOUT6
ANO
ANO signal output
16
VIN6
21
VIN7
22
VOUT7
FMOD
FM modulation signal output
During transmission in FM mode : FF
23
VOUT8
SMOD
SSB modulation signal output
During transmission in modes other than FM mode : FF
24
VIN8
During VGS-1 recording standby time/constant recording
CODEC output signal input
CODEC output signal input
CODEC output signal input
Mixer : TC4107F (RF Unit IC251)
Mixer : NJM1496V (TX-RX Unit IC621)
■ Equivalent circuit
■ Equivalent circuit
6
5
Vo (+)
6
2
Carrier –
input +
4
3
REG1
REG2
Signal –
input +
10
8
4
1
8
1
Bias
Buffer : HD74LV541AT (TX-RX Unit IC222)
■ Logic diagram
A1
2
Gain
adjust
3
7
G1
G2
Vo (–)
12
2
Inputs
18
Y1
To seven other channels
14
■ Function table
1
19
V–
5
Output
G1
G2
A1
Y1
L
L
L
L
L
L
H
H
H
X
X
Z
X
H
X
Z
H : High level
L : Low level
X : Immaterial
Z : High impedance
25
TS-480HX/480SAT
SEMICONDUCTOR DATA
CODEC : AK4550VT (TX-RX Unit IC217)
■ Block diagram
■ Pin function
AINL
∆Σ
modulator
Decimation
filter
AINR
∆Σ
modulator
Decimation
filter
VCOM
Clock
divider
LRCK
SCLK
LPF
AOUTR
LPF
SDTO
SDTI
Serial I/O
inteface
Common voltage
AOUTL
MCLK
∆Σ
modulator
8X
interpolator
∆Σ
modulator
8X
interpolator
DEM0
DEM1
PWDA
PWAD
VDD
VSS
No.
Name
I/O
1
VCOM
O
Function
2
AINR
I
Rch analog input
3
AINL
I
Lch analog input
4
VSS
-
Ground
5
VDD
-
Power supply
6
DEM0
I
De-emphasis control
7
DEM1
I
De-emphasis control
8
SDTO
O
Audio serial data output
9
SFTI
I
Audio serial data input
10
LRCK
I
Input/output channel clock
11
MCLK
I
Master clock input
12
SCLK
I
Audio serial data clock
13
PWAD
I
ADC power down & reset mode
14
PWDA
I
DAC power down & reset mode
15
AOUTL
O
Lch analog output
16
AOUTR
O
Rch analog output
Common voltage output, 0.45 x VDD
“L” : Power down
“L” : Power down
D/A : M62353AGP (TX-RX Unit IC681)
■ Block diagram
■ Pin function
No.
GND
16
AO1
15
DI
14
CLK
13
AO1
LD
12
DO
11
D0
D1
D2
D3
D4
D5
D6
D7
D8
D9
D10
D11
8bit D-A
converter
VCC
9
AO8
12bit shift register
– +
AO8
10
– +
Address
decoder (8)
8bit latch
8bit latch
8bit latch
8bit latch
8bit latch
8bit latch
8bit D-A
converter
8bit D-A
converter
8bit D-A
converter
8bit D-A
converter
8bit D-A
converter
8bit D-A
converter
– +
– +
– +
– +
– +
– +
AO2
1
VSS
(VrefL)
2
AO2
AO3
3
AO3
AO4
4
AO4
AO5
5
AO5
DI
Serial data input
11
DO
Serial data output
13
CLK
Serial clock input
12
LD
LD terminal input high level then
15
AO1
8 bit D-A converter output
2
AO2
3
AO3
4
AO4
5
AO5
6
AO6
7
AO7
10
AO8
9
VCC
Power supply
16
GND
Digiital and analog common GND
8
VDD
D-A converter high level reference
1
VSS
latch circuit data load
8bit latch
(8)
AO6
6
AO6
AO7
7
AO7
Function
14
8bit D-A
converter
(8)
8bit latch
Name
8
VDD
(VrefU)
voltage input
D-A converter low level reference
voltage input
26
TS-480HX/480SAT
PARTS LIST
✽ New Parts.
indicates safety critical components.
Parts without Parts No. are not supplied.
Les articles non mentionnes dans le Parts No. ne sont pas fournis.
Teile ohne Parts No. werden nicht geliefert.
L : Scandinavia
Y : PX (Far East, Hawaii)
Y : AAFES (Europe)
K : USA
T : England
X : Australia
P : Canada
E : Europe
M : Other Areas
TS-480HX/480SAT (Y52-328X-XX)
Ref. No.
New
Address parts
Parts No.
Description
Destination
TS-480HX/480SAT
1
2
3
3
4
1B
1D,1F
3A,3F
3A,3D
3G
✽
✽
✽
✽
✽
A01-2189-02
A01-2190-02
A10-4061-01
A10-4062-01
A62-1076-03
CABINET (UPPER)
CABINET (LOWER)
CHASSIS
CHASSIS
PANEL ASSY
5
6
3A
1H
✽
✽
A62-1079-01
A82-0052-11
PANEL
REAR PANEL
8
9
10
11
12
1B
1D,1F
1C,1E
1J
1D,1F
✽
B03-3610-03
B42-2455-04
B42-5650-04
B42-7003-04
B42-7019-04
DRESSING PLATE
STICKER
S/NO. LABEL
RATING LABEL (DC CORD)
STANDARD LABEL (FCC)
14
15
14
17
18
1C,1E
1B
1C,1E
1K
1K
✽
✽
B42-7070-04
B42-7116-04
B42-7126-04
B52-0619-00
B52-0620-10
STANDARD LABEL (FCC)
STICKER (ANT)
STANDARD LABEL (E-MARK)
SCHEMATIC DIAGRAM
SCHEMATIC DIAGRAM
19
20
21
22
23
1K
1K
1K
1K
1K
✽
✽
✽
✽
✽
B62-1735-10
B62-1736-10
B62-1750-10
B62-1751-10
B62-1752-10
INSTRUCTION MANUAL (ENGLISH)
INSTRUCTION MANUAL (GERMANY)
INSTRUCTION MANUAL (FRENCH)
INSTRUCTION MANUAL (ITALIAN)
INSTRUCTION MANUAL (SPANISH)
EH,ES
EH,ES
EH,ES
EH,ES
24
25
25
25
25
1K
1E
1C
1E
1C
✽
✽
✽
✽
✽
B62-1753-10
B72-2166-04
B72-2167-04
B72-2168-04
B72-2169-04
INSTRUCTION MANUAL (DOUCHE)
MODEL NAME PLATE
MODEL NAME PLATE
MODEL NAME PLATE
MODEL NAME PLATE
EH,ES
KH
KS
EH
ES
27
28
29
30
-
3B
1J
1J,2J
1J
✽
✽
✽
✽
E30-3009-15
E30-3488-05
E30-3489-05
E30-3500-05
E37-1059-05
ANTENNA CABLE (ANT)
MODULAR CABLE (PANEL, 4M)
DC CORD
MODULAR CABLE (PANEL, 20CM)
EH,ES
LEAD WIRE WITH CONNECTOR (X57 CN369)
-
✽
✽
✽
✽
✽
E37-1060-05
E37-1061-05
E37-1062-05
E37-1063-05
E37-1064-05
LEAD WIRE WITH MINIPIN PLUG (X57 CN501)
LEAD WIRE WITH MINIPIN PLUG (X57 CN3)
LEAD WIRE WITH MINIPIN PLUG (X57 CN1)
LEAD WIRE WITH MINIPIN PLUG (X44 CN2)
LEAD WIRE WITH MINIPIN PLUG (X44 CN1)
39
40
41
2A,2D,2F
2A
2B
✽
✽
✽
✽
✽
E37-1067-05
E37-1068-05
E37-1069-05
E37-1070-05
E37-1071-05
LEAD WIRE WITH MINIPIN PLUG (X45 CN504) KS,ES
LEAD WIRE WITH MINIPIN PLUG (X45 CN505) KS,ES
FLAT CABLE (X57 CN395,403)
FLAT CABLE (X57 CN375)
FLAT CABLE (X45 CN501)
42
43
44
45
1G
2A
1K
1K
✽
✽
✽
✽
E37-1072-05
E37-1073-05
E57-0404-05
E57-0405-05
LEAD WIRE WITH CONNECTOR (SP)
LEAD WIRE WITH CONNECTOR (EXT. AT)
DIN PLUG (6P ACC)
DIN PLUG (8P ACC)
47
48
49
50
51
1J,1K
2D,2F,1K
3C,3E
3A
3C
✽
✽
✽
F05-2531-05
F06-4027-05
F07-1874-05
F07-1875-13
F07-1878-04
FUSE (BLADE) (25A/32V)
FUSE (BLADE) (4A/32V)
COVER (FAN)
COVER (DIN, SP, KEY)
COVER (FAN)
52
53
3C,3E
2D,2F
✽
✽
F09-0478-05
F10-2450-02
FAN MOTOR
SHIELDING COVER (X45 A/3)
KH : TS-480HX (K)
EH : TS-480HX (E)
KS : TS-480SAT (K)
ES : TS-480SAT (E)
KH,EH
KS,ES
EH,ES
KH,KS
KH,KS
EH,ES
KH,KS
KH,KS
Ref. No.
New
Address parts
Parts No.
Description
Destination
✽
✽
✽
F10-2456-03
F10-2470-02
F15-1007-04
SHIELDING COVER (X57 A/2)
SHIELDING COVER (X45 B/3)
SHIELDING PLATE (DC2)
3G
2A
3G
3G
1B
✽
✽
G02-0505-05
G02-0570-04
G02-0898-04
G09-0405-05
G10-1305-04
KNOB SPRING
FLAT SPRING (X57 IC734)
FLAT SPRING (TORQUE LEVER)
KNOB SPRING
FIBROUS SHEET
63
64
65
66
67
1B
1D,1F
3A
3A
3A
✽
✽
✽
✽
✽
G10-1306-04
G10-1307-04
G10-1308-04
G10-1309-04
G10-1310-04
FIBROUS SHEET
FIBROUS SHEET
FIBROUS SHEET
FIBROUS SHEET
FIBROUS SHEET
68
69
70
71
1H
3G
✽
✽
1B
1K
✽
G10-1311-04
G10-1313-14
G10-1326-04
G10-1328-04
G11-4228-04
FIBROUS SHEET
FIBROUS SHEET
FIBROUS SHEET
FIBROUS SHEET
SHEET
72
73
74
75
76
1H
1K
3H
2H,3H
2H,3H
G11-4245-04
G11-4269-04
G11-4270-04
G11-4278-04
G11-4287-04
SHEET
SHEET
SHEET
SHEET
SHEET
77
78
79
80
81
2A
2F
2H
1J
1H
✽
✽
G13-1871-05
G13-1872-05
G13-1888-04
G13-2022-14
G13-2024-04
CONDUCTIVE CUSHION
CONDUCTIVE CUSHION
CUSHION
CUSHION
CUSHION
82
1H
✽
G53-1559-02
PACKING
83
84
85
86
87
2J
2K
2K
1K
1J,2J
✽
✽
✽
H12-3142-02
H12-3153-02
H12-3154-02
H25-0029-04
H25-0796-04
PACKING FIXTURE
PACKING FIXTURE
PACKING FIXTURE
PROTECTION BAG (60/110/0.07)
PROTECTION BAG
88
89
90
91
92
1K
1K
1J,1K
1J,1K
1K,2K
PROTECTION BAG (80✽180 T=0.08)
PROTECTION BAG
PROTECTION BAG (100/250/0.07)
PROTECTION BAG
PROTECTION BAG (250/350/0.07)
EH,ES
✽
✽
✽
H25-2013-04
H25-2320-04
H25-2327-04
H25-2343-04
H25-2352-04
93
93
93
93
3K
3K
3K
3K
✽
✽
✽
✽
H52-1944-02
H52-1945-02
H52-1946-02
H52-1947-02
ITEM CARTON CASE
ITEM CARTON CASE
ITEM CARTON CASE
ITEM CARTON CASE
KH
KS
EH
ES
95
96
97
98
99
1D,1F
1K
1G
1J
1K
✽
✽
✽
✽
J02-0441-05
J09-0409-03
J21-8449-04
J29-0663-13
J29-0705-01
FOOT
STAND
HARDWARE FIXTURE
BRACKET
BRACKET
EH,ES
100
101
-
1K
1K
✽
✽
J29-0706-04
J29-0707-03
J61-0307-05
BRACKET
BRACKET
BAND
104
105
106
1J
3G
3H
✽
✽
K01-0420-05
K21-1105-03
K29-9263-02
HANDLE
KNOB (MAIN DIAL)
KEY TOP
54
55
56
2A
2B
3C
58
59
60
61
62
✽
✽
✽
✽
KS,ES
KH,EH
KS,ES
EH,ES
27
TS-480HX/480SAT
PARTS LIST
TS-480HX/480SAT
RF UNIT (X44-327X-XX)
Ref. No.
New
Address parts
107
108
109
110
111
3G
3G
3G
3G
3G
114
115
✽
✽
✽
✽
✽
Parts No.
Destination
Description
KNOB RING
KNOB
KNOB
KNOB
KNOB
1J,1K
1K
L79-1408-05
L79-1417-05
LINE FILTER (WITH BAND)
LINE FILTER
A
B
C
D
E
3G
3D,3F
3G
✽
1B,1D,1F
3C
✽
N14-0582-14
N15-1040-46
N19-0670-05
N33-2606-45
N35-3014-45
CIRCULAR NUT
FLAT WASHER
SPECIAL WASHER
OVAL HEAD MACHINE SCREW
BINDING HEAD MACHINE SCREW
F
G
H
J
K
3D,3F
3C,3E
2D,2F
1H
1G
N35-4010-46
N66-3020-45
N67-2608-46
N80-2016-45
N82-2605-46
BINDING HEAD MACHINE SCREW
PAN HEAD SEMS SCREW B
PAN HEAD SEMS SCREW W
PAN HEAD TAPTITE SCREW
BINDING HEAD TAPTITE SCREW
L
117
118
2B,2D,2F
1K
✽
1J
✽
N87-2608-46
N99-2035-05
N99-2041-05
BRAZIER HEAD TAPTITE SCREW
SCREW SET
SCREW SET
121
122
1G
1K
✽
T07-0298-05
T91-0638-05
SPEAKER
MICROPHONE
124
2H
✽
W02-1836-15
ENCODER
126
126
2F
2D
✽
✽
X58-4900-00
X58-4900-01
SUB UNIT
SUB UNIT
EH,ES
CHIP C
ELECTRO
CHIP C
CHIP C
CHIP C
1000PF
470UF
0.010UF
39PF
0.010UF
K
16WV
K
J
K
C6
C7
C8
C10
C11
CK73FB1C105K
CK73GB1C104K
CC73GCH1H470J
CK73GB1C104K
CC73GCH1H080B
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
1.0UF
0.10UF
47PF
0.10UF
8.0PF
K
K
J
K
B
C12
C13
C14
C15
C16
CC73GCH1H470J
CK73FB1E104K
CK73GB1H103K
CK73EB1H104K
CK73GB1H102K
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
47PF
0.10UF
0.010UF
0.10UF
1000PF
J
K
K
K
K
C17
C18
C19
C20
C22
CK73GB1C104K
CK73EB1H104K
CK73GB1C104K
CK73GB1H103K
CK73GB1H103K
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
0.10UF
0.10UF
0.10UF
0.010UF
0.010UF
K
K
K
K
K
C23
C24
C25
C26
C28
CC73FCH1H150J
CK73GB1H103K
CE04EW1E4R7M
CK73GB1H103K
CK73FB1E104K
CHIP C
CHIP C
ELECTRO
CHIP C
CHIP C
15PF
0.010UF
4.7UF
0.010UF
0.10UF
J
K
25WV
K
K
C29
C30
C32
C33
CK73FB1C105K
CK73FB1H102K
C90-4111-05
CC73GCH1H180J
CHIP C
CHIP C
ELECTRO
CHIP C
1.0UF
1000PF
470UF
18PF
K
K
16WV
J
28
✽
Parts No.
Destination
Description
CC73FCH1H152J
CK73GB1C104K
CC73FCH1H222J
CC73FCH1H152J
CC73FCH1H222J
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
1500PF
0.10UF
2200PF
1500PF
2200PF
J
K
J
J
J
CC73FCH1H122J
CK73GB1C104K
CC73FCH1H182J
CK73GB1C104K
CC73GCH1H821J
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
1200PF
0.10UF
1800PF
0.10UF
820PF
J
K
J
K
J
C65
C66
C67
C68
C69
CK73GB1C104K
CC73GCH1H681J
CK73GB1C104K
CC73GCH1H471J
CK73GB1C104K
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
0.10UF
680PF
0.10UF
470PF
0.10UF
K
J
K
J
K
C70
C71
C72
C73
C74
CC73GCH1H331J
CK73GB1C104K
CC73GCH1H221J
CK73GB1C104K
CC73GCH1H560J
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
330PF
0.10UF
220PF
0.10UF
56PF
J
K
J
K
J
C75
C76
C77
C78
C79
CK73GB1C104K
CC73GCH1H121J
CK73GB1C104K
CC73GCH1H221J
CC73GCH1H102J
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
0.10UF
120PF
0.10UF
220PF
1000PF
K
J
K
J
J
C80
C81-88
C89
C90
C91
CC73FCH1H222J
CC73GCH1H102J
CC73GCH1H560J
CC73FCH1H122J
CC73GCH1H680J
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
2200PF
1000PF
56PF
1200PF
68PF
J
J
J
J
J
C92
C93
C94
C95
C96
CC73GCH1H471J
CC73GCH1H331J
CC73GCH1H101J
CC73GCH1H680J
CC73GCH1H151J
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
470PF
330PF
100PF
68PF
150PF
J
J
J
J
J
C97
C98
C99-107
C108
C109
CC73GCH1H820J
CK73GB1H103K
CC73GCH1H102J
CK73FB1C105K
CK73GB1C104K
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
82PF
0.010UF
1000PF
1.0UF
0.10UF
J
K
J
K
K
CC73FCH1H122J
CK73GB1C104K
CC73FCH1H182J
CK73GB1C104K
CC73GCH1H821J
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
1200PF
0.10UF
1800PF
0.10UF
820PF
J
K
J
K
J
C115
C116
C117
C118
C119
CK73GB1C104K
CC73GCH1H681J
CK73GB1C104K
CC73GCH1H471J
CK73GB1C104K
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
0.10UF
680PF
0.10UF
470PF
0.10UF
K
J
K
J
K
C120
C121
C122
C123
C124
CC73GCH1H331J
CK73GB1C104K
CC73GCH1H221J
CK73GB1C104K
CC73GCH1H560J
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
330PF
0.10UF
220PF
0.10UF
56PF
J
K
J
K
J
C125
C126
C127
C128
C129,130
CK73GB1C104K
CC73GCH1H181J
CK73GB1C104K
CC73FCH1H222J
CC73GCH1H090B
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
0.10UF
180PF
0.10UF
2200PF
9.0PF
K
J
K
J
B
C60
C61
C62
C63
C64
✽
EH,ES
2-71 : EH,ES
CK73FB1H102K
C90-4111-05
CK73GB1H103K
CC73GCH1H390J
CK73GB1H103K
✽
KS,ES
KH,EH
KS,ES
RF UNIT (X44-327X-XX) 0-00 : KH,KS
C1
C2
C3
C4
C5
New
Address parts
C51
C52
C53,54
C55
C56-59
K29-9264-04
K29-9265-03
K29-9266-03
K29-9267-03
K29-9270-03
✽
Ref. No.
C110
C111
C112
C113
C114
✽
✽
KH : TS-480HX (K)
EH : TS-480HX (E)
EH,ES
KS : TS-480SAT (K)
ES : TS-480SAT (E)
TS-480HX/480SAT
PARTS LIST
RF UNIT (X44-327X-XX)
Ref. No.
New
Address parts
Parts No.
Destination
Description
Ref. No.
New
Address parts
Parts No.
Destination
Description
C131
C151
C152
C153
C154
CC73GCH1H150J
CK73GB1H103K
CK73GB1H102K
CK73GB1C104K
CK73FB1E104K
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
15PF
0.010UF
1000PF
0.10UF
0.10UF
J
K
K
K
K
C285-287
C288
C290
C291
C292
CK73GB1H103K
CK73GB1H102K
CK73GB1H103K
CC73GCH1H090B
CC73GCH1H220J
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
0.010UF
1000PF
0.010UF
9.0PF
22PF
K
K
K
B
J
C155
C156
C157
C158
C159
CK73GB1H103K
CC73GCH1H050B
CK73GB1C104K
CC73GCH1H560J
CK73GB1C104K
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
0.010UF
5.0PF
0.10UF
56PF
0.10UF
K
B
K
J
K
C293
C295
C297
C298
C301
CK73GB1H103K
CK73GB1C104K
CC73GCH1H330J
CK73GB1H103K
CK73GB1H103K
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
0.010UF
0.10UF
33PF
0.010UF
0.010UF
K
K
J
K
K
C161
C162
C163
C164
C165
CC73GCH1H150J
CC73GCH1H820J
CC73GCH1H390J
CK73GB1H103K
CC73GCH1H330J
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
15PF
82PF
39PF
0.010UF
33PF
J
J
J
K
J
C302
C303-305
C321-325
TC51,52
CK73GB1C104K
CK73GB1H102K
CK73GB1H102K
C05-0385-05
CHIP C
0.10UF
K
CHIP C
1000PF K
CHIP C
1000PF K
CERAMIC TRIMMER CAP (20PF)
C166,167
C168
C169
C170,171
C173
CK73FB1E104K
CK73GB1C104K
CK73FB1E104K
CK73GB1C104K
CK73GB1C104K
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
0.10UF
0.10UF
0.10UF
0.10UF
0.10UF
K
K
K
K
K
CN1,2
CN4
CN51,52
CN152
E18-0254-05
E04-0154-05
E40-5487-05
E40-5487-05
E40-0211-05
SOCKET
PIN SOCKET
PIN ASSY
PIN ASSY
PIN ASSY
C174
C176
C177,178
C179
C180
CC73GCH1H102J
CK73GB1H102K
CK73GB1H103K
CK73GB1H102K
CK73FB1E104K
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
1000PF
1000PF
0.010UF
1000PF
0.10UF
J
K
K
K
K
CN153
CN252
CN253
CN254
CN309
E04-0154-05
E40-0211-05
E04-0154-05
E04-0191-05
E40-5978-05
PIN SOCKET
PIN ASSY
PIN SOCKET
PIN SOCKET
FLAT CABLE CONNECTOR
J301,302
E11-0455-05
3.5D PHONE JACK (3P)
C181
C182
C184
C185
C186
CK73GB1H103K
CC73GCH1H020B
CK73GB1H102K
CK73GB1H471K
CK73GB1H103K
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
0.010UF
2.0PF
1000PF
470PF
0.010UF
K
B
K
K
K
F10-2462-04
F10-2478-04
F10-2483-04
F10-2493-04
F20-3320-04
SHIELDING CASE
SHIELDING CASE
SHIELDING CASE
SHIELDING CASE
INSULATING SHEET
C187
C188
C190
C191,192
C193
CK73GB1C104K
CK73GB1H471K
CK73GB1H102K
CK73GB1H103K
CC73GCH1H020B
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
0.10UF
470PF
1000PF
0.010UF
2.0PF
K
K
K
K
B
L40-1005-34
L40-1085-34
L40-4705-34
L40-1005-34
L41-1585-09
SMALL FIXED INDUCTOR (10UH)
SMALL FIXED INDUCTOR (100NH)
SMALL FIXED INDUCTOR (47UH)
SMALL FIXED INDUCTOR (10UH)
SMALL FIXED INDUCTOR
C194
C195
C196
C198
C200
CK73GB1H102K
CC73GCH1H010B
CC73GCH1H030B
CK73GB1H102K
CK73GB1H103K
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
1000PF
1.0PF
3.0PF
1000PF
0.010UF
K
B
B
K
K
L33-0695-05
L33-0695-05
L41-2785-08
L41-1085-08
L41-6895-09
SMALL FIXED INDUCTOR
SMALL FIXED INDUCTOR
SMALL FIXED INDUCTOR
SMALL FIXED INDUCTOR
SMALL FIXED INDUCTOR
C201
C252
C253-255
C256-258
C259
CK73GB1H102K
CK73GB1H103K
CK73GB1C104K
CK73GB1H103K
CK73GB1H471K
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
1000PF
0.010UF
0.10UF
0.010UF
470PF
K
K
K
K
K
✽
L33-0695-05
L41-6895-09
L41-5695-09
L33-0695-05
L41-6895-09
SMALL FIXED INDUCTOR
SMALL FIXED INDUCTOR
SMALL FIXED INDUCTOR
SMALL FIXED INDUCTOR
SMALL FIXED INDUCTOR
C260
C261
C262,263
C266,267
C268
CK73GB1H103K
CC73GUJ1H040C
CK73GB1H103K
CK73GB1H102K
CC73GCH1H010B
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
0.010UF
4.0PF
0.010UF
1000PF
1.0PF
K
C
K
K
B
L58
L59
L60
L61
L62
✽
✽
✽
✽
✽
L41-2295-09
L41-1595-09
L41-1095-09
L41-4785-08
L41-3985-08
SMALL FIXED INDUCTOR
SMALL FIXED INDUCTOR
SMALL FIXED INDUCTOR
SMALL FIXED INDUCTOR
SMALL FIXED INDUCTOR
C269-271
C272
C273
C274
C275
CK73GB1H102K
CK73GB1C104K
CK73GB1H102K
CK73GB1H103K
CC73GCH1H060B
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
1000PF
0.10UF
1000PF
0.010UF
6.0PF
K
K
K
K
B
L63
L64
L65
L66
L67
✽
✽
✽
✽
L41-2785-08
L41-1885-08
L41-1585-08
L34-4569-05
L41-6895-09
SMALL FIXED INDUCTOR
SMALL FIXED INDUCTOR
SMALL FIXED INDUCTOR
AIR-CORE COIL
SMALL FIXED INDUCTOR
C276
C277
C278-280
C281
C282
CK73GB1H102K
CK73GB1H103K
CK73GB1H102K
CC73GCH1H010B
CK73GB1H103K
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
1000PF
0.010UF
1000PF
1.0PF
0.010UF
K
K
K
B
K
✽
✽
✽
L33-0695-05
L41-5695-09
L41-6885-09
L41-1895-09
SMALL FIXED INDUCTOR
SMALL FIXED INDUCTOR
SMALL FIXED INDUCTOR
SMALL FIXED INDUCTOR
KH : TS-480HX (K)
EH : TS-480HX (E)
KS : TS-480SAT (K)
ES : TS-480SAT (E)
L1
L2
L3,4
L5
L6
L7
L9
L10
L11
L51
L52
L53
L54
L55
L56,57
L68
L69
L70
L71
✽
✽
✽
✽
✽
✽
✽
✽
✽
EH,ES
EH,ES
EH,ES
29
TS-480HX/480SAT
PARTS LIST
RF UNIT (X44-327X-XX)
Ref. No.
New
Address parts
Parts No.
Destination
Description
Ref. No.
New
Address parts
Parts No.
Destination
Description
L72
L73
L74
L75
L77
✽
✽
✽
✽
L41-1295-09
L41-2795-09
L41-2295-09
L41-2785-08
L33-0695-05
SMALL FIXED INDUCTOR
SMALL FIXED INDUCTOR
SMALL FIXED INDUCTOR
SMALL FIXED INDUCTOR
SMALL FIXED INDUCTOR
R15
R16
R17
R18,19
R20,21
RK73GB1J101J
RK73GB1J222J
RK73GB1J151J
RK73FB2A560J
RK73GB1J472J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
100
2.2K
150
56
4.7K
J
J
J
J
J
1/16W
1/16W
1/16W
1/10W
1/16W
L78
L79
L80
L81
L82
✽
✽
✽
✽
✽
L41-2295-09
L41-1595-09
L41-1095-09
L41-4785-08
L41-3985-08
SMALL FIXED INDUCTOR
SMALL FIXED INDUCTOR
SMALL FIXED INDUCTOR
SMALL FIXED INDUCTOR
SMALL FIXED INDUCTOR
R22
R51-60
R61
R62-70
R71-80
R92-0670-05
RK73FB2A470J
RK73GB1J471J
RK73GB1J330J
RK73FB2A470J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
0 OHM
47
470
33
47
J
J
J
J
1/10W
1/16W
1/16W
1/10W
L83
L84
L85
L86
L87
✽
✽
✽
L41-2785-08
L41-1885-08
L41-1585-08
L34-4569-05
L41-2785-08
SMALL FIXED INDUCTOR
SMALL FIXED INDUCTOR
SMALL FIXED INDUCTOR
AIR-CORE COIL
SMALL FIXED INDUCTOR
R81
R82
R151
R152
R153,154
RK73GB1J560J
RK73GB1J472J
RK73GB1J103J
RK73FB2A221J
RK73FB2A121J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
56
4.7K
10K
220
120
J
J
J
J
J
1/16W
1/16W
1/16W
1/10W
1/10W
L33-0695-05
L39-1476-05
L40-3385-34
L40-3391-37
L41-1585-08
SMALL FIXED INDUCTOR
TOROIDAL COIL
SMALL FIXED INDUCTOR (330NH)
SMALL FIXED INDUCTOR (3.3UH)
SMALL FIXED INDUCTOR
R155
R156
R157
R158
R159
RK73GB1J682J
RK73GB1J104J
RK73GB1J473J
RK73GB1J182J
RK73GB1J473J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
6.8K
100K
47K
1.8K
47K
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
L41-1085-08
L39-1476-05
L39-1480-05
L40-4785-34
L40-1015-34
SMALL FIXED INDUCTOR
TOROIDAL COIL
TOROIDAL COIL
SMALL FIXED INDUCTOR (470NH)
SMALL FIXED INDUCTOR (100UH)
R160
R161-164
R165
R167
R168
RK73GB1J471J
RK73GB1J100J
RK73GB1J683J
RK73FB2A470J
RK73GB1J470J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
470
10
68K
47
47
J
J
J
J
J
1/16W
1/16W
1/16W
1/10W
1/16W
L40-4705-34
L40-1015-34
L34-4709-05
L40-1005-34
L34-4408-05
SMALL FIXED INDUCTOR (47UH)
SMALL FIXED INDUCTOR (100UH)
COIL
SMALL FIXED INDUCTOR (10UH)
COIL
R170
R172
R173
R174
R175
R92-1252-05
RK73GB1J562J
RK73GB1J100J
RK73FB2A471J
RK73FB2A561J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
0 OHM
5.6K
10
470
560
J
J
J
J
J
1/16W
1/16W
1/16W
1/10W
1/10W
L40-1015-34
L39-1476-05
L39-1480-05
L40-4705-34
L40-3985-34
SMALL FIXED INDUCTOR (100UH)
TOROIDAL COIL
TOROIDAL COIL
SMALL FIXED INDUCTOR (47UH)
SMALL FIXED INDUCTOR (390NH)
R176
R177,178
R179
R181
R182,183
RK73GB1J473J
RK73GB1J681J
RK73GB1J120J
RK73GB1J102J
RK73GB1J100J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
47K
680
12
1.0K
10
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
L40-1085-34
L40-4785-34
L40-1005-34
L40-4705-34
L39-1480-05
SMALL FIXED INDUCTOR (100NH)
SMALL FIXED INDUCTOR (470NH)
SMALL FIXED INDUCTOR (10UH)
SMALL FIXED INDUCTOR (47UH)
TOROIDAL COIL
R184
R185
R186,187
R188
R189
RK73GB1J271J
RK73GB1J220J
RK73GB1J100J
RK73GB1J471J
RK73GB1J681J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
270
22
10
470
680
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
L40-4785-34
L39-1480-05
L40-4785-34
L40-1091-37
L71-0605-05
SMALL FIXED INDUCTOR (470NH)
TOROIDAL COIL
SMALL FIXED INDUCTOR (470NH)
SMALL FIXED INDUCTOR (1.000UH)
MCF (73.095MHZ)
R190
R191
R192
R193
R194
RK73GB1J103J
RK73GB1J102J
RK73GB1J333J
RK73GB1J103J
RK73FB2A100J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
10K
1.0K
33K
10K
10
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/10W
CP302,303
R1
R2
R3
R4
RK75GB1J103J
RK73GB1J821J
RK73GB1J6R8J
RK73GB1J821J
RK73EB2B560J
CHIP-COM
CHIP R
CHIP R
CHIP R
CHIP R
10K
820
6.8
820
56
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/8W
R195
R196
R197
R198
R199,200
RK73GB1J102J
R92-1252-05
RK73GB1J331J
RK73GB1J102J
RK73GB1J331J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
1.0K
0 OHM
330
1.0K
330
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R5
R6
R7
R8
R9
RK73GB1J103J
RK73GB1J102J
RK73EB2B471J
RK73EB2B181J
RK73FB2A100J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
10K
1.0K
470
180
10
J
J
J
J
J
1/16W
1/16W
1/8W
1/8W
1/10W
R202
R204,205
R206
R251
R253
RK73FB2A221J
RK73GB1J222J
RK73GB1J102J
RK73GB1J470J
RK73FB2A101J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
220
2.2K
1.0K
47
100
J
J
J
J
J
1/10W
1/16W
1/16W
1/16W
1/10W
R10
R11
R12
R13
R14
RK73GB1J473J
RK73GB1J331J
RK73GB1J681J
RK73GB1J103J
RK73GB1J333J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
47K
330
680
10K
33K
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R254
R255,256
R257
R258
R259
RK73GB1J820J
RK73GB1J102J
R92-1252-05
RK73GB1J471J
RK73GB1J331J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
82
1.0K
0 OHM
470
330
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
L151
L152
L153
L154
L155
L156
L157,158
L159
L160
L161
L162
L163
L164
L165
L166-168
L251
L252
L253
L254
L255
L256
L257,258
L259
L260,261
L262
L263
L264
L265
L301-305
XF151
30
✽
✽
✽
✽
✽
✽
✽
✽
✽
✽
✽
✽
KH : TS-480HX (K)
EH : TS-480HX (E)
KS : TS-480SAT (K)
ES : TS-480SAT (E)
TS-480HX/480SAT
PARTS LIST
RF UNIT (X44-327X-XX)
FINAL UNIT (X45-365X-XX)
Ref. No.
New
Address parts
Parts No.
Destination
Description
Ref. No.
R260
R262,263
R264
R265
R266
R92-1252-05
RK73GB1J331J
RK73GB1J470J
RK73GB1J474J
RK73GB1J100J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
0 OHM
330
47
470K
10
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
D256
D301-304
IC251
IC301
Q1
R268
R269
R270
R271
R275
RK73GB1J103J
RK73GB1J392J
RK73GB1J332J
RK73GB1J182J
RK73GB1J100J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
10K
3.9K
3.3K
1.8K
10
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
Q2
Q3
Q4
Q51-60
Q151
R276
R277
R278,279
R280
R281
RK73GB1J471J
RK73GB1J103J
RK73GB1J331J
RK73GB1J470J
R92-1252-05
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
470
10K
330
47
0 OHM
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
Q152
Q153,154
Q155
Q156,157
Q158
R282
R283
R284
R285
R286
RK73GB1J331J
RK73GB1J100J
RK73GB1J124J
RK73GB1J331J
RK73GB1J220J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
330
10
120K
330
22
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
Q159
Q160,161
Q251
Q252
Q253
R287
R288
R289
R290
R291
RK73GB1J331J
RK73GB1J180J
RK73GB1J331J
RK73GB1J470J
RK73GB1J101J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
330
18
330
47
100
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
Q255
Q256
Q301,302
TH251
R292
R293
R294
R295
R296
R92-1252-05
RK73GB1J330J
RK73GB1J221J
RK73GB1J471J
RK73GB1J220J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
0 OHM
33
220
470
22
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
D100
R297
R298
R301
R313
R314
RK73GB1J470J
RK73GB1J681J
RK73GB1J101J
RK73GB1J473J
R92-1252-05
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
47
680
100
47K
0 OHM
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R315
R316,317
R401
RK73GB1J473J
RK73GB1J103J
R92-1061-05
CHIP R
47K
CHIP R
10K
JUMPER REST
K1
S51-1428-05
D1
D2
D3,4
D5
D51,52
D53
D54
D55
D56-59
D60
D61-69
D151
D152
D154,155
D156
D251
D252
D253
D254
D255
KH : TS-480HX (K)
EH : TS-480HX (E)
✽
✽
New
Address parts
Parts No.
HSB88WS
1SS388
TA4107F
BU2099FV
KRA318E
DIODE
DIODE
MOS IC
MOS IC
DIGITAL TRANSISTOR
HN7G01FU
2SK2596
2SD1757K
KRA318E
KRC402E
TRANSISTOR
FET
TRANSISTOR
DIGITAL TRANSISTOR
DIGITAL TRANSISTOR
✽
RN47A5
3SK131(M)
KRC418E
2SK520(K44)
HN7G01FU
TRANSISTOR
FET
DIGITAL TRANSISTOR
FET
TRANSISTOR
✽
2SK2596
2SK520(K44)
2SK1830
2SC3356
3SK317
FET
FET
FET
TRANSISTOR
FET
2SC3356
KRC418E
KRC402E
157-101-65001
TRANSISTOR
DIGITAL TRANSISTOR
DIGITAL TRANSISTOR
THERMISTOR
✽
✽
✽
✽
✽
✽
Destination
Description
FINAL UNIT (X45-365X-XX) 0-11 : KS
✽
2-71 : ES
B30-2263-15
LED (R/LOWER)
C6,7
C9,10
C13,14
C16
C17
CK73FB1E104K
CK73FB1E104K
CK73FB1E104K
CK73FB1H102K
CK73FB1E104K
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
0.10UF
0.10UF
0.10UF
1000PF
0.10UF
K
K
K
K
K
RELAY
C18
C19
C21
C22
C23
CE04EW1E100M
CE04EW1E331M
CK73FB1E104K
CK73FB1H103K
CK73FB1E104K
ELECTRO
ELECTRO
CHIP C
CHIP C
CHIP C
10UF
330UF
0.10UF
0.010UF
0.10UF
25WV
25WV
K
K
K
MA2S111
V08(G)
RLS245
V08(G)
HVC131
DIODE
DIODE
DIODE
DIODE
DIODE
C27
C28
C29
C30
C32
CK73FB1H103K
CK73FB1E104K
CE04EW1E101M
CE04EW1E331M
CM73F2H181J
CHIP C
CHIP C
ELECTRO
ELECTRO
CHIP C
0.010UF
0.10UF
100UF
330UF
180PF
K
K
25WV
25WV
J
LFB01
HVC131
RN731V
1SV312
HVC131
DIODE
DIODE
DIODE
DIODE
DIODE
C33,34
C35,36
C37,38
C39
C40,41
CE04EW1E100M
CK73FB1E104K
C93-0716-05
CE04EW1E100M
CK73FB1E104K
ELECTRO
CHIP C
CHIP C
ELECTRO
CHIP C
10UF
0.10UF
3300PF
10UF
0.10UF
25WV
K
K
25WV
K
HSC277
HSC277
1SV312
DAN235E
HSC277
DIODE
DIODE
DIODE
DIODE
DIODE
C42
C43-45
C46,47
C48
C49
CE04EW1E221M
CK73FB1E104K
CM73F2H331J
CK73FB1E104K
CE04EW1E101M
ELECTRO
CHIP C
CHIP C
CHIP C
ELECTRO
220UF
0.10UF
330PF
0.10UF
100UF
25WV
K
J
K
25WV
HSC277
DAN235E
MA2S111
RN731V
DAN235E
DIODE
DIODE
DIODE
DIODE
DIODE
C50
C51,52
C53
C54
C55
CK73FB1E104K
C93-0560-05
C91-2691-05
CE04EW1E471M
CK73FB1E104K
CHIP C
CHIP C
CERAMIC
ELECTRO
CHIP C
0.10UF
10PF
470PF
470UF
0.10UF
K
D
250WV
25WV
K
KS : TS-480SAT (K)
ES : TS-480SAT (E)
J
1/16W
J
1/16W
0 OHM
✽
31
TS-480HX/480SAT
PARTS LIST
FINAL UNIT (X45-365X-XX)
Ref. No.
New
Address parts
Parts No.
Destination
Description
Ref. No.
New
Address parts
Parts No.
Destination
Description
C57
C58,59
C61
C62
C63
CE04EW1E471M
CK73FB1H103K
CK73FB1E104K
CK73FB1H102K
CK73FB1E104K
ELECTRO
CHIP C
CHIP C
CHIP C
CHIP C
470UF
0.010UF
0.10UF
1000PF
0.10UF
25WV
K
K
K
K
C306
C307
C309
C310
C311
CC45FSL2H270J
CC45FSL2H271J
C93-0569-05
CC45FSL2H181J
CK73FB1H103K
CERAMIC
CERAMIC
CHIP C
CERAMIC
CHIP C
27PF
270PF
56PF
180PF
0.010UF
J
J
J
J
K
C64
C65
C66
C67
C68
CE04EW1E100M
CK73FB1H102K
CK73FB1H103K
C90-4116-05
CK73FB1H103K
ELECTRO
CHIP C
CHIP C
ELECTRO
CHIP C
10UF
1000PF
0.010UF
22UF
0.010UF
25WV
K
K
16WV
K
C312
C352
C354
C355
C356
C93-0554-05
CC45FSL2H101J
C93-0558-05
CC45FSL2H271J
CC45FSL2H470J
CHIP C
CERAMIC
CHIP C
CERAMIC
CERAMIC
4.0PF
100PF
8.0PF
270PF
47PF
C
J
D
J
J
CK73FB1H102K
C93-0568-05
CM73F2H221J
CE04EW1HR22M
CK73FB1H103K
CHIP C
CHIP C
CHIP C
ELECTRO
CHIP C
1000PF
47PF
220PF
0.22UF
0.010UF
K
J
J
50WV
K
C357
C359
C402
C403
C404
CC45FSL2H151J
CK73FB1H103K
CC45FSL2H330J
CC45FSL2H560J
CC45FSL2H121J
CERAMIC
CHIP C
CERAMIC
CERAMIC
CERAMIC
150PF
0.010UF
33PF
56PF
120PF
J
K
J
J
J
C93-0716-05
CK73FB1H103K
CM73F2H271J
CK73FB1H102K
CK73FB1H103K
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
3300PF
0.010UF
270PF
1000PF
0.010UF
K
K
J
K
K
C405
C407
C408
C410
C411
CC45FSL2H180J
CC45FSL2H151J
CC45FSL2H050C
CC45FSL2H820J
CK73FB1H103K
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CHIP C
18PF
150PF
5.0PF
82PF
0.010UF
J
J
C
J
K
C80
C81
C90-93
C94
C95
CK73FB1H102K
CK73FB1E104K
CK45FB1H103K
C93-0572-05
C93-0568-05
CHIP C
CHIP C
CERAMIC
CHIP C
CHIP C
1000PF
0.10UF
0.010UF
100PF
47PF
K
K
K
J
J
C412
C413
C451
C452
C454
C93-0562-05
C93-0563-05
CK73FB1H103K
CC45FSL2H220J
C93-0555-05
CHIP C
CHIP C
CHIP C
CERAMIC
CHIP C
15PF
18PF
0.010UF
22PF
5.0PF
J
J
K
J
C
C96
C97
C102
C103
C104
C93-0572-05
C93-0568-05
CM73F2H102J
CM73F2H561J
CC45FSL2H680J
CHIP C
CHIP C
CHIP C
CHIP C
CERAMIC
100PF
47PF
1000PF
560PF
68PF
J
J
J
J
J
C456
C458
C459
C461
C462
CC45FSL2H560J
C93-0563-05
CC45FSL2H560J
C93-0563-05
CC45FSL2H220J
CERAMIC
CHIP C
CERAMIC
CHIP C
CERAMIC
56PF
18PF
56PF
18PF
22PF
J
J
J
J
J
C105
C106
C107
C108
C109
CM73F2H102J
CM73F2H821J
CC45FSL2H121J
CC45FSL2H680J
CM73F2H102J
CHIP C
CHIP C
CERAMIC
CERAMIC
CHIP C
1000PF
820PF
120PF
68PF
1000PF
J
J
J
J
J
C463
C502
C503
C504
C505
CK73FB1H103K
CK73FB1H102K
CK73FB1H103K
CC73FCH1H680J
CK73FB1E104K
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
0.010UF
1000PF
0.010UF
68PF
0.10UF
K
K
K
J
K
C111
C152
C154
C155
C157
CK73FB1H103K
CM73F2H561J
CC45FSL2H331J
CM73F2H102J
CC45FSL2H151J
CHIP C
CHIP C
CERAMIC
CHIP C
CERAMIC
0.010UF
560PF
330PF
1000PF
150PF
K
J
J
J
J
C506
C507
C508
C509
C511-522
CK73FB1H102K
CC45FCH2H030C
CC73FCH1H560J
CK73FB1H102K
CK73FB1H103K
CHIP C
CERAMIC
CHIP C
CHIP C
CHIP C
1000PF
3.0PF
56PF
1000PF
0.010UF
K
C
J
K
K
C158
C159
C202
C203,204
C205
CM73F2H561J
CK73FB1H103K
CC45FSL2H181J
CC45FSL2H121J
CM73F2H561J
CHIP C
CHIP C
CERAMIC
CERAMIC
CHIP C
560PF
0.010UF
180PF
120PF
560PF
J
K
J
J
J
C523
C525,526
C527
C528
C529
CK73FB1H102K
CK73FB1H103K
CE04EW1C470M
CK73FB1H103K
CC73FCH1H470J
CHIP C
CHIP C
ELECTRO
CHIP C
CHIP C
1000PF
0.010UF
47UF
0.010UF
47PF
K
K
16WV
K
J
C206
C207
C208
C209
C210
C93-0570-05
C93-0569-05
CM73F2H681J
C93-0567-05
CC45FSL2H391J
CHIP C
CHIP C
CHIP C
CHIP C
CERAMIC
68PF
56PF
680PF
39PF
390PF
J
J
J
J
J
C530
C531
C535
C536
C537
CK73FB1H103K
CC73FCH1H470J
CK73FB1H103K
CC73FCH1H100D
CC73FCH1H080D
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
0.010UF
47PF
0.010UF
10PF
8.0PF
K
J
K
D
D
C211
C212
C252
C254
C255,256
CK73FB1H103K
C93-0570-05
CC45FSL2H151J
CC45FSL2H470J
CC45FSL2H221J
CHIP C
CHIP C
CERAMIC
CERAMIC
CERAMIC
0.010UF
68PF
150PF
47PF
220PF
K
J
J
J
J
C801
C802
C803,804
C805
C806,807
CK73FB1H102K
CK73FB1E104K
CK73FB1H103K
CK73FB1E104K
CK73FB1H103K
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
1000PF
0.10UF
0.010UF
0.10UF
0.010UF
K
K
K
K
K
C257
C258
C259
C260
C304
C93-0560-05
CC45FSL2H101J
CC45FSL2H271J
CK73FB1H103K
CC45FSL2H181J
CHIP C
CERAMIC
CERAMIC
CHIP C
CERAMIC
10PF
100PF
270PF
0.010UF
180PF
D
J
J
K
J
C808
C809-814
C815
C816-821
C822
CK73FB1E104K
CK73FB1H103K
CK73FB1E104K
CK73FB1H103K
CK73FB1E104K
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
0.10UF
0.010UF
0.10UF
0.010UF
0.10UF
K
K
K
K
K
✽
C69
C70
C71
C72
C73
C74,75
C76
C77
C78
C79
32
✽
KH : TS-480HX (K)
EH : TS-480HX (E)
KS : TS-480SAT (K)
ES : TS-480SAT (E)
TS-480HX/480SAT
PARTS LIST
FINAL UNIT (X45-365X-XX)
Ref. No.
New
Address parts
Parts No.
Destination
Description
Ref. No.
C823,824
C825,826
C827-832
C833-836
C837-844
C91-3115-05
CK73FB1H103K
C91-3115-05
CK73FB1H103K
C91-3115-05
HV CAP
CHIP C
HV CAP
CHIP C
HV CAP
10PF
0.010UF
10PF
0.010UF
10PF
2KV
K
2KV
K
2KV
L14
L15
L16,17
L18
L19
C845-848
C849,850
C851-854
C855,856
C857-860
CK73FB1H103K
C91-3126-05
CK73FB1H103K
C91-3127-05
CK73FB1H103K
CHIP C
HV CAP
CHIP C
HV CAP
CHIP C
0.010UF
10PF
0.010UF
18PF
0.010UF
K
3KV
K
3KV
K
L20
L21
L24
L25,26
L27
C861-864
C865-868
C869-872
C873-876
C877,878
C91-3127-05
CK73FB1H103K
C91-3123-05
CK73FB1H103K
C91-3123-05
HV CAP
CHIP C
HV CAP
CHIP C
HV CAP
18PF
0.010UF
150PF
0.010UF
150PF
3KV
K
3KV
K
3KV
L28
L29
L30-35
L36
L90,91
C879-882
C883,884
C885-887
C888
C889
CK73FB1H103K
C91-3123-05
CK73FB1H103K
C91-3123-05
CK73FB1H103K
CHIP C
HV CAP
CHIP C
HV CAP
CHIP C
0.010UF
150PF
0.010UF
150PF
0.010UF
K
3KV
K
3KV
K
C890
C891,892
C893,894
C895-910
TC501
C91-3123-05
CK73FB1H103K
CK73FB1E104K
CK73FB1H103K
C05-0031-15
HV CAP
150PF
3KV
CHIP C
0.010UF K
CHIP C
0.10UF
K
CHIP C
0.010UF K
CERAMIC TRIMMER CAP (10P)
CN1
CN2
CN3
CN4
CN5
E04-0154-05
E40-5978-05
E40-5608-05
E40-5607-05
E40-3246-05
CN8
CN9
CN11
CN12,13
CN101
CN102
CN501
CN502
CN503-505
CN819,820
New
Address parts
Parts No.
Description
L39-1434-05
L39-1450-05
L33-0699-05
L39-1451-05
L40-4795-34
TOROIDAL COIL
TOROIDAL COIL
CHOKE COIL
TOROIDAL COIL
SMALL FIXED INDUCTOR (4.7UH)
L33-0651-05
L39-1490-05
L33-0617-15
L92-0131-05
L34-1231-15
CHOKE COIL
TOROIDAL COIL
CHOKE COIL
FERRITE CHIP
AIR-CORE COIL
L39-1485-05
L92-0131-05
L33-0699-05
L92-0149-05
L39-0421-04
TOROIDAL COIL
FERRITE CHIP
CHOKE COIL
FERRITE CHIP
COIL
L101
L102
L103
L151
L152
L40-4705-34
L39-1259-05
L39-1260-05
L40-4705-34
L39-1405-05
SMALL FIXED INDUCTOR (47UH)
TOROIDAL COIL
TOROIDAL COIL
SMALL FIXED INDUCTOR (47UH)
TOROIDAL COIL
L153
L201
L202
L203,204
L251
L39-1225-05
L40-4705-34
L39-1266-05
L39-1223-05
L40-4705-34
TOROIDAL COIL
SMALL FIXED INDUCTOR (47UH)
TOROIDAL COIL
TOROIDAL COIL
SMALL FIXED INDUCTOR (47UH)
PIN SOCKET
FLAT CABLE CONNECTOR
PIN ASSY
PIN ASSY
PIN ASSY
L252,253
L301
L302
L303,304
L351
L39-1221-05
L40-4705-34
L34-1278-05
L39-1221-05
L40-4705-34
TOROIDAL COIL
SMALL FIXED INDUCTOR (47UH)
AIR-CORE COIL
TOROIDAL COIL
SMALL FIXED INDUCTOR (47UH)
E40-3252-05
E40-3246-05
E04-0154-05
E23-0996-05
E40-5734-05
PIN ASSY
PIN ASSY
PIN SOCKET
TEST TERMINAL
FLAT CABLE CONNECTOR
L352
L353
L401
L402
L403,404
L34-1279-05
L34-1280-05
L40-4705-34
L34-4661-05
L34-1281-05
AIR-CORE COIL
AIR-CORE COIL
SMALL FIXED INDUCTOR (47UH)
AIR-CORE COIL
AIR-CORE COIL
E04-0191-05
E40-5739-05
E40-5758-05
E04-0190-05
E04-0154-05
PIN SOCKET
FLAT CABLE CONNECTOR
FLAT CABLE CONNECTOR
PIN SOCKET
PIN SOCKET
L405
L451
L452
L453
L454
L92-0131-05
L40-4705-34
L34-4662-05
L34-4491-05
L34-1359-05
FERRITE CHIP
SMALL FIXED INDUCTOR (47UH)
AIR-CORE COIL
AIR-CORE COIL
AIR-CORE COIL
E37-1056-05
E37-1104-05
LEAD WIRE WITH TERMINAL
LEAD WIRE WITH TERMINAL
F1
F2
F3
F53-0093-05
F53-0108-05
F06-4027-05
FUSE
FUSE
FUSE (BLADE) (4A/32V)
L455
L501
L502
L503
L504
L92-0131-05
L40-1021-33
L39-0480-15
L40-1005-85
L40-1021-33
FERRITE CHIP
SMALL FIXED INDUCTOR
TOROIDAL COIL
SMALL FIXED INDUCTOR (10UH)
SMALL FIXED INDUCTOR
CN6,7
J13-0410-05
FUSE HOLDER
L1
L92-0104-05
L92-0105-05
L92-0107-05
L92-0108-05
L40-1505-34
TROIDAL CORE
TROIDAL CORE
TROIDAL CORE
TROIDAL CORE
SMALL FIXED INDUCTOR (15UH)
L505
L506
L507-510
L511
L801-803
L39-1442-05
L39-1443-05
L40-4705-34
L41-1585-09
L39-1441-05
TOROIDAL COIL
TOROIDAL COIL
SMALL FIXED INDUCTOR (47UH)
SMALL FIXED INDUCTOR
TOROIDAL COIL
L2
L6
L7
L8
L11
L40-1005-34
L92-0149-05
L39-1488-05
L92-0131-05
L33-0699-05
SMALL FIXED INDUCTOR (10UH)
FERRITE CHIP
TOROIDAL COIL
FERRITE CHIP
CHOKE COIL
L804
L805
L806,807
L808
L809
L40-1001-12
L39-1441-05
L39-1440-05
L40-4705-34
L34-4633-05
SMALL FIXED INDUCTOR
TOROIDAL COIL
TOROIDAL COIL
SMALL FIXED INDUCTOR (47UH)
AIR-CORE COIL
L40-1001-12
L39-1491-15
SMALL FIXED INDUCTOR
TOROIDAL COIL
L810
L811
L812
L813
L814
L40-4705-34
L34-4630-05
L40-4705-34
L34-4490-05
L40-4705-34
SMALL FIXED INDUCTOR (47UH)
AIR-CORE COIL
SMALL FIXED INDUCTOR (47UH)
AIR-CORE COIL
SMALL FIXED INDUCTOR (47UH)
W1
W1
L12
L13
KH : TS-480HX (K)
EH : TS-480HX (E)
✽
✽
✽
✽
KS : TS-480SAT (K)
ES : TS-480SAT (E)
KS
KS
ES
✽
✽
✽
Destination
33
TS-480HX/480SAT
PARTS LIST
FINAL UNIT (X45-365X-XX)
Ref. No.
New
Address parts
Parts No.
Destination
Description
Ref. No.
New
Address parts
Parts No.
Destination
Description
L815
L816
L817
L818
L819
L34-4490-05
L40-4705-34
L34-4628-05
L40-4705-34
L34-4490-05
AIR-CORE COIL
SMALL FIXED INDUCTOR (47UH)
AIR-CORE COIL
SMALL FIXED INDUCTOR (47UH)
AIR-CORE COIL
R512,513
R514,515
R516,517
R518,519
R520,521
RK73FB2A104J
RK73FB2A103J
RK73FB2A152J
RK73FB2A102J
RK73FB2A105J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
100K
10K
1.5K
1.0K
1.0M
J
J
J
J
J
1/10W
1/10W
1/10W
1/10W
1/10W
L820
L821
L822-838
L891
L40-4705-34
L34-4490-05
L40-4705-34
L40-4705-34
SMALL FIXED INDUCTOR (47UH)
AIR-CORE COIL
SMALL FIXED INDUCTOR (47UH)
SMALL FIXED INDUCTOR (47UH)
R530
R531-534
R535-538
R539
R550
RK73FB2A153J
RK73FB2A101J
RK73FB2A104J
RK73FB2A103J
RK73FB2A391J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
15K
100
100K
10K
390
J
J
J
J
J
1/10W
1/10W
1/10W
1/10W
1/10W
R1,2
R3
R4
R5
R7,8
RK73FB2A470J
RK73FB2A331J
RK73FB2A470J
RK73FB2A100J
RK73FB2A470J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
47
330
47
10
47
J
J
J
J
J
1/10W
1/10W
1/10W
1/10W
1/10W
R552
R553
R554
R891
VR1-3
RK73FB2A472J
RK73FB2A182J
R92-1061-05
RK73FB2A471J
R12-6737-05
CHIP R
4.7K
J
1/10W
CHIP R
1.8K
J
1/10W
JUMPER REST
0 OHM
CHIP R
470
J
1/10W
TRIMMING POT. (3.3K)
R10
R11
R12
R14
R15
RK73FB2A221J
RK73FB2A100J
RK73FB2A122J
RK73FB2A470J
RK73FB2A220J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
220
10
1.2K
47
22
J
J
J
J
J
1/10W
1/10W
1/10W
1/10W
1/10W
VR501
VR502
W501-506
R12-6730-05
R12-6742-05
R92-0150-05
TRIMMING POT. (220)
TRIMMING POT. (22K)
JUMPER REST
0 OHM
R16
R17
R18
R19
R20
RK73FB2A391J
RK73FB2A102J
RK73FB2A332J
RK73FB2A102J
RK73FB2A562J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
390
1.0K
3.3K
1.0K
5.6K
J
J
J
J
J
1/10W
1/10W
1/10W
1/10W
1/10W
K101,102
K151,152
K201,202
K251,252
K301,302
S76-0423-05
S76-0423-05
S76-0423-05
S76-0423-05
S76-0423-05
RELAY
RELAY
RELAY
RELAY
RELAY
R21,22
R23
R24
R25
R28
RK73FB2A470J
RS14DB3D101J
RK73EB2B391J
R92-3510-05
R92-3510-05
CHIP R
FL-PROOF RS
CHIP R
CHIP R
CHIP R
47
100
390
2.2
2.2
J
J
J
J
J
1/10W
2W
1/8W
1W
1W
K351,352
K401,402
K451,452
K501
K502,503
S76-0423-05
S51-1420-05
S51-1420-05
S51-1429-05
S76-0424-05
RELAY
RELAY
RELAY
RELAY
RELAY
R29,30
R31,32
R33
R34
R35
R92-3511-05
R92-1240-05
RK73FB2A103J
RK73FB2A223J
R92-3559-05
CHIP R
CHIP R
CHIP R
CHIP R
METAL FILM R
8.2
10
10K
22K
0.01
J
J
J
J
J
1/2W
1/4W
1/10W
1/10W
10W
K801-808
K809-824
K891
S76-0415-05
S76-0419-05
S76-0415-05
RELAY
RELAY
RELAY
R92-1274-05
R92-0696-05
RK73FB2A223J
RK73FB2A103J
RK73FB2A470J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
56
33
22K
10K
47
J
J
J
J
J
1/2W
1/4W
1/10W
1/10W
1/10W
D1,2
D3
D4
D101
D151
MA27-B
ZSH5MA27
1SS355
1SS355
1SS355
VARISTOR
SURGE ABSORBER
DIODE
DIODE
DIODE
R92-3574-05
RK73FB2A223J
RK73FB2A103J
RK73FB2A681J
RK73FB2A822J
RESISTOR
CHIP R
CHIP R
CHIP R
CHIP R
0.1
22K
10K
680
8.2K
J
J
J
J
J
2W
1/10W
1/10W
1/10W
1/10W
D201
D251
D301
D351
D401
1SS355
1SS355
1SS355
1SS355
1SS355
DIODE
DIODE
DIODE
DIODE
DIODE
R53
R54
R55
R56-61
R90,91
R92-2018-05
RS14DB3A101J
RK73FB2A100J
RK73EB2B1R0J
RS14DB3F820J
CHIP R
FL-PROOF RS
CHIP R
CHIP R
FL-PROOF RS
560
100
10
1.0
82
J
J
J
J
J
1/2W
1W
1/10W
1/8W
3W
D451
D501,502
D503
D504,505
D506,507
1SS355
1SS348
1SS355
HSM88AS
1SS355
DIODE
DIODE
DIODE
DIODE
DIODE
R92
R101-105
R501
R502
R503
RS14DB3A4R7J
R92-0679-05
RK73FB2A100J
R92-0686-05
R92-1212-05
FL-PROOF RS
CHIP R
CHIP R
CHIP R
CHIP R
4.7
0 OHM
10
33
27
J
1W
D508,509
D801-824
D891
IC1
IC2
DSA301LA
1SS355
1SS355
TA7805F
TA7808F
DIODE
DIODE
DIODE
MOS IC
ANALOG IC
J
J
J
1/10W
1/2W
1/2W
R504
R505
R506,507
R508,509
R510,511
RK73FB2A102J
R92-1316-05
RK73FB2A101J
RK73FB2A102J
RK73FB2A101J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
1.0K
39
100
1.0K
100
J
J
J
J
J
1/10W
1W
1/10W
1/10W
1/10W
IC501
IC502
IC503
IC509,510
IC801-803
BU2099FV
TA75S393F
TC7WH74FU
TC7SHU04F
UPD6345GS
MOS IC
MOS IC
MOS IC
MOS IC
MOS IC
IC804,805
Q1
Q2
TC7WT125FU
2SK2596
2SK2595
MOS IC
FET
FET
✽
R36
R37
R38
R39
R42
R47
R49
R50
R51
R52
34
✽
KS
KH : TS-480HX (K)
EH : TS-480HX (E)
KS
KS
KS : TS-480SAT (K)
ES : TS-480SAT (E)
TS-480HX/480SAT
PARTS LIST
FINAL UNIT (X45-365X-XX)
FINAL UNIT (X45-366X-XX)
Ref. No.
New
Address parts
Parts No.
Destination
Description
Ref. No.
New
Address parts
Parts No.
Destination
Description
2SC3421(Y)
2SC2782
SI7445DP
DTC114EKA
2SD1757K
TRANSISTOR
TRANSISTOR
FET
DIGITAL TRANSISTOR
TRANSISTOR
C75
C76-78
C79
C80
C81
CE04EW1HR22M
CK45FB1H103K
CK73FB1E104K
CM73F2H331J
CM73F2H391J
ELECTRO
CERAMIC
CHIP C
CHIP C
CHIP C
0.22UF
0.010UF
0.10UF
330PF
390PF
50WV
K
K
J
J
Q10
Q11
Q501-505
Q506,507
Q508
2SJ305
DTC114EKA
FMA5A
2SK208(GR)
RN47A5
FET
DIGITAL TRANSISTOR
TRANSISTOR
FET
TRANSISTOR
C102
C103
C104
C105
C106
CM73F2H102J
CM73F2H561J
C93-0570-05
CM73F2H102J
CM73F2H821J
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
1000PF
560PF
68PF
1000PF
820PF
J
J
J
J
J
Q891
TH1
DTC114EKA
157-153-53002
DIGITAL TRANSISTOR
THERMISTOR
-
212-1021-05
INSULATING TUBE
C107
C108
C109
C111
C152
CC45FSL2H121J
C93-0570-05
CM73F2H102J
CK73FB1H103K
CM73F2H561J
CERAMIC
CHIP C
CHIP C
CHIP C
CHIP C
120PF
68PF
1000PF
0.010UF
560PF
J
J
J
K
J
C153
C154
C155
C156
C158
C93-0565-05
CC45FSL2H221J
CM73F2H102J
CC45FSL2H151J
CC45FSL2H101J
CHIP C
CERAMIC
CHIP C
CERAMIC
CERAMIC
27PF
220PF
1000PF
150PF
100PF
J
J
J
J
J
Q3
Q4,5
Q6
Q7
Q8,9
✽
KS
FINAL UNIT (X45-366X-XX) 0-00 : KH 2-71 : EH
D100
✽
B30-2263-15
LED (R)
C4,5
C8
C10-12
C13
C14
CK73FB1E104K
CK73FB1E104K
CK73FB1E104K
CK73FB1C105K
CK73FB1E104K
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
0.10UF
0.10UF
0.10UF
1.0UF
0.10UF
K
K
K
K
K
C159
C160
C202
C203,204
C205
CM73F2H681J
CK73FB1H103K
CM73F2H221J
C93-0572-05
C93-0571-05
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
680PF
0.010UF
220PF
100PF
82PF
J
K
J
J
J
C15
C17
C18
C20
C21,22
CK73FB1H102K
CK73FB1E104K
CE04EW1E100M
CE04EW1E471M
CK73FB1E104K
CHIP C
CHIP C
ELECTRO
ELECTRO
CHIP C
1000PF
0.10UF
10UF
470UF
0.10UF
K
K
25WV
25WV
K
C206
C207
C208
C209
C210
C93-0570-05
CM73F2H471J
C93-0570-05
C93-0569-05
CM73F2H561J
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
68PF
470PF
68PF
56PF
560PF
J
J
J
J
J
CK73FB1E103K
C90-4116-05
CK73FB1E104K
CK73FB1E103K
CE04EW1E331M
CHIP C
ELECTRO
CHIP C
CHIP C
ELECTRO
0.010UF
22UF
0.10UF
0.010UF
330UF
K
25WV
K
K
25WV
C211
C212
C213
C214
C215
C93-0572-05
C93-0567-05
CM73F2H331J
C93-0563-05
CK73FB1H103K
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
100PF
39PF
330PF
18PF
0.010UF
J
J
J
J
K
CM73F2H561J
CE04EW1E100M
CK73FB1E104K
C93-0716-05
CE04EW1E100M
CHIP C
ELECTRO
CHIP C
CHIP C
ELECTRO
560PF
10UF
0.10UF
3300PF
10UF
J
25WV
K
K
25WV
C253
C254
C255
C256
C257
C93-0570-05
C93-0567-05
CC45FSL2H391J
C93-0567-05
C93-0566-05
CHIP C
CHIP C
CERAMIC
CHIP C
CHIP C
68PF
39PF
390PF
39PF
33PF
J
J
J
J
J
C43,44
C46-48
C49
C50
C51
CK73FB1E104K
CK73FB1E104K
CM73F2H391J
CM73F2H331J
CK73FB1E104K
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
0.10UF
0.10UF
390PF
330PF
0.10UF
K
K
J
J
K
C259
C261
C305
C306
C307,308
CC45FSL2H271J
CK73FB1H103K
CC45FSL2H151J
CC45FSL2H121J
C93-0564-05
CERAMIC
CHIP C
CERAMIC
CERAMIC
CHIP C
270PF
0.010UF
150PF
120PF
22PF
J
K
J
J
J
C52
C53
C54
C55
C56
CE04EW1E101M
CK73FB1E104K
CE04EW1E471M
CK73FB1E104K
C91-2691-05
ELECTRO
CHIP C
ELECTRO
CHIP C
CERAMIC
100UF
0.10UF
470UF
0.10UF
470PF
25WV
K
25WV
K
250WV
C309
C310
C311
C313
C315
CC45FSL2H151J
CC45FSL2H181J
C93-0564-05
CC45FSL2H101J
CK73FB1H103K
CERAMIC
CERAMIC
CHIP C
CERAMIC
CHIP C
150PF
180PF
22PF
100PF
0.010UF
J
J
J
J
K
C57
C60
C61
C62
C63
CK73FB1E104K
CM73F2H331J
CK73FB1H103K
CK73FB1H102K
CE04EW1E471M
CHIP C
CHIP C
CHIP C
CHIP C
ELECTRO
0.10UF
330PF
0.010UF
1000PF
470UF
K
J
K
K
25WV
C355
C356
C357
C358
C359
C93-0564-05
CC45FSL2H181J
C93-0565-05
CC45FSL2H221J
C93-0568-05
CHIP C
CERAMIC
CHIP C
CERAMIC
CHIP C
22PF
180PF
27PF
220PF
47PF
J
J
J
J
J
CK73FB1H103K
C93-0716-05
CK45FB1H103K
CK73FB1E104K
CK73FB1H103K
CHIP C
CHIP C
CERAMIC
CHIP C
CHIP C
0.010UF
3300PF
0.010UF
0.10UF
0.010UF
K
K
K
K
K
C360
C362
C363
C402
C403
C93-0560-05
CC45FSL2H151J
CK73FB1H103K
CC45FSL2H151J
C93-0570-05
CHIP C
CERAMIC
CHIP C
CERAMIC
CHIP C
10PF
150PF
0.010UF
150PF
68PF
D
J
K
J
J
C23
C27
C29
C31,32
C34
C35
C36,37
C38,39
C40,41
C42
C64,65
C66-71
C72
C73
C74
KH : TS-480HX (K)
EH : TS-480HX (E)
✽
✽
✽
KS : TS-480SAT (K)
ES : TS-480SAT (E)
35
TS-480HX/480SAT
PARTS LIST
FINAL UNIT (X45-366X-XX)
Ref. No.
New
Address parts
Parts No.
Destination
Description
C406
C408
C409
C410
C412
C93-0563-05
CC45FSL2H181J
C93-0560-05
C93-0555-05
C93-0571-05
CHIP C
CERAMIC
CHIP C
CHIP C
CHIP C
18PF
180PF
10PF
5.0PF
82PF
J
J
D
C
J
C413
C451
C452
C453
C454
CK73FB1H103K
CK73FB1H103K
C93-0567-05
C93-0565-05
C93-0571-05
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
0.010UF
0.010UF
39PF
27PF
82PF
K
K
J
J
J
C455
C456
C457
C459
C460
C93-0562-05
C93-0556-05
C93-0572-05
C93-0568-05
CK73FB1H103K
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
15PF
6.0PF
100PF
47PF
0.010UF
J
D
J
J
K
C461,462
C463
C464
C465
C501
C93-0569-05
C93-0567-05
C93-0555-05
C93-0565-05
CK73FB1H102K
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
56PF
39PF
5.0PF
27PF
1000PF
J
J
C
J
K
C502
C503
C504
C505
C506
CK73FB1H103K
CC73FCH1H680J
CK73FB1E104K
CK73FB1H102K
CC45FCH2H030C
CHIP C
CHIP C
CHIP C
CHIP C
CERAMIC
0.010UF
68PF
0.10UF
1000PF
3.0PF
K
J
K
K
C
C507
C508
C509,510
C511,512
C535
CC73FCH1H560J
CK73FB1H102K
CK73FB1H103K
CC73FCH1H470J
CK73FB1H103K
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
56PF
1000PF
0.010UF
47PF
0.010UF
J
K
K
J
K
C536
C800
C801
C803
C804
CC73GCH1H080D
CM73F2H391J
CM73F2H560J
CE04EW1E100M
CK73FB1E104K
CHIP C
CHIP C
CHIP C
ELECTRO
CHIP C
8.0PF
390PF
56PF
10UF
0.10UF
D
J
J
25WV
K
C805
C806
C807
C808,809
C810
CM73F2H561J
CK73FB1E104K
CE04EW1E100M
C93-0716-05
CK73FB1E104K
CHIP C
CHIP C
ELECTRO
CHIP C
CHIP C
560PF
0.10UF
10UF
3300PF
0.10UF
J
K
25WV
K
K
C811
C812
C814
C816
C817
CM73F2H391J
CM73F2H331J
CK73FB1E104K
CE04EW1E101M
CK73FB1E104K
CHIP C
CHIP C
CHIP C
ELECTRO
CHIP C
390PF
330PF
0.10UF
100UF
0.10UF
J
J
K
25WV
K
C819
C821
C822
C823
C824
CM73F2H560J
C91-2691-05
CE04EW1E471M
CM73F2H331J
CK73FB1E104K
CHIP C
CERAMIC
ELECTRO
CHIP C
CHIP C
56PF
470PF
470UF
330PF
0.10UF
J
250WV
25WV
J
K
C826
C827
C828
C829
C830-835
CK73FB1E104K
CK73FB1H103K
CE04EW1HR22M
CK45FB1H103K
C93-0716-05
CHIP C
CHIP C
ELECTRO
CERAMIC
CHIP C
0.10UF
0.010UF
0.22UF
0.010UF
3300PF
K
K
50WV
K
K
CK45FB1H103K
CK73FB1E104K
CE04CW1E100M
CK45FB1H103K
C93-0553-05
CERAMIC
CHIP C
ELECTRO
CERAMIC
CHIP C
0.010UF
0.10UF
10UF
0.01UF
3.0PF
K
K
25WV
K
C
C836
C837
C838
C839,840
C841
36
✽
✽
Ref. No.
New
Address parts
Parts No.
Destination
Description
C842
C843
TC501
CC73FCH1H180J
CC73FCH1H222J
C05-0031-15
CHIP C
18PF
J
CHIP C
2200PF J
CERAMIC TRIMMER CAP (10PF)
CN1
CN2
CN3
CN4
CN5
E04-0154-05
E40-5978-05
E40-5608-05
E40-5607-05
E40-3246-05
PIN SOCKET
FLAT CABLE CONNECTOR
PIN ASSY
PIN ASSY
PIN ASSY
CN8
CN9,10
CN12,13
CN101
CN501
E40-3252-05
E40-3246-05
E23-0996-05
E40-5734-05
E40-5739-05
PIN ASSY
PIN ASSY
TEST TERMINAL
FLAT CABLE CONNECTOR
FLAT CABLE CONNECTOR
CN502
CN503
CN829,830
W1
W1
✽
✽
E40-5758-05
E04-0190-05
E23-0996-05
E37-1056-05
E37-1104-05
FLAT CABLE CONNECTOR
PIN SOCKET
TEST TERMINAL
LEAD WIRE WITH TERMINAL
LEAD WIRE WITH TERMINAL
KH
EH
W101
W801
W801
✽
✽
✽
E37-1105-05
E37-1056-05
E37-1104-05
LEAD WIRE WITH MINIPIN PLUG
LEAD WIRE WITH TERMINAL
LEAD WIRE WITH TERMINAL
KH
EH
F3
F4
F801
F06-4027-05
F53-0110-05
F53-0093-05
FUSE (BLADE) (4A/32V)
FUSE
FUSE
CN6,7
J13-0410-05
FUSE HOLDER
L1
L2
L3
L92-0104-05
L92-0105-05
L40-4705-34
L40-1005-34
L92-0131-05
TROIDAL CORE
TROIDAL CORE
SMALL FIXED INDUCTOR (47UH)
SMALL FIXED INDUCTOR (10UH)
FERRITE CHIP
L5
L6
L7
L8
L9
L92-0131-05
L92-0149-05
L39-1483-05
L92-0131-05
L33-0699-05
FERRITE CHIP
FERRITE CHIP
TOROIDAL COIL
FERRITE CHIP
CHOKE COIL
L92-0131-05
L39-1482-15
L40-1001-12
L39-1487-05
L39-1450-05
FERRITE CHIP
TOROIDAL COIL
SMALL FIXED INDUCTOR
TOROIDAL COIL
TOROIDAL COIL
L33-0699-05
L39-1451-05
L40-4795-34
L33-0651-05
L39-1490-05
CHOKE COIL
TOROIDAL COIL
SMALL FIXED INDUCTOR (4.7UH)
CHOKE COIL
TOROIDAL COIL
L33-0617-15
L92-0131-05
L39-1485-05
L33-0699-05
L40-4705-34
CHOKE COIL
FERRITE CHIP
TOROIDAL COIL
CHOKE COIL
SMALL FIXED INDUCTOR (47UH)
L39-1259-05
L39-1260-05
L40-4705-34
L39-1486-05
L39-0458-05
TOROIDAL COIL
TOROIDAL COIL
SMALL FIXED INDUCTOR (47UH)
TOROIDAL COIL
TOROIDAL COIL
L40-4705-34
L39-0463-05
L39-1440-05
SMALL FIXED INDUCTOR (47UH)
TOROIDAL COIL
TOROIDAL COIL
L11
L12
L13
L14
L15
L16,17
L18
L19
L20
L21
L24
L25,26
L27
L28
L101
L102
L103
L151
L152
L153
L201
L202
L203,204
✽
✽
✽
✽
✽
✽
KH : TS-480HX (K)
EH : TS-480HX (E)
KS : TS-480SAT (K)
ES : TS-480SAT (E)
TS-480HX/480SAT
PARTS LIST
FINAL UNIT (X45-366X-XX)
Ref. No.
New
Address parts
Parts No.
Destination
Description
Ref. No.
New
Address parts
Parts No.
Destination
Description
L251
L252
L253
L301
L302
L40-4705-34
L39-0463-05
L39-0460-05
L40-4705-34
L34-1359-05
SMALL FIXED INDUCTOR (47UH)
TOROIDAL COIL
TOROIDAL COIL
SMALL FIXED INDUCTOR (47UH)
AIR-CORE COIL
R25
R26
R28
R29
R32
RK73FB2A332J
RK73FB2A562J
RK73EB2B391J
R92-2673-05
R92-2673-05
CHIP R
CHIP R
CHIP R
CHIP R
RESISTOR
3.3K
5.6K
390
1.0
1.0
J
J
J
J
J
1/10W
1/10W
1/8W
1W
1W
L303,304
L351
L352
L353,354
L401
L39-1492-05
L40-4705-34
L34-1281-05
L34-1279-05
L40-4705-34
TOROIDAL COIL
SMALL FIXED INDUCTOR (47UH)
AIR-CORE COIL
AIR-CORE COIL
SMALL FIXED INDUCTOR (47UH)
R33,34
R35,36
R37
R38
R39
R92-3511-05
R92-1240-05
RK73FB2A103J
RK73FB2A223J
R92-3559-05
RESISTOR
CHIP R
CHIP R
CHIP R
METAL FILM R
8.2
10
10K
22K
0.01
J
J
J
J
J
1/2W
1/4W
1/10W
1/10W
10W
L402
L403,404
L405
L451
L452
L34-4661-05
L34-1281-05
L92-0131-05
L40-4705-34
L34-1359-05
AIR-CORE COIL
AIR-CORE COIL
FERRITE CHIP
SMALL FIXED INDUCTOR (47UH)
AIR-CORE COIL
R40,41
R42,43
R49-54
R55
R56
R92-1245-05
R92-1374-05
RK73EB2B1R0J
RK73FB2A100J
RK73FB2A4R7J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
47
47
1.0
10
4.7
J
J
J
J
J
1/2W
1/4W
1/8W
1/10W
1/10W
L453,454
L455
L501
L502
L503
L34-4662-05
L92-0131-05
L40-2221-33
L39-0480-15
L40-1005-85
AIR-CORE COIL
FERRITE CHIP
SMALL FIXED INDUCTOR
TOROIDAL COIL
SMALL FIXED INDUCTOR (10UH)
R58-63
R64,65
R66
R67
R80
R92-0679-05
RS14DB3F820J
R92-0670-05
R92-2536-05
RS14DB3D101J
CHIP R
FL-PROOF RS
CHIP R
CHIP R
FL-PROOF RS
0 OHM
82
J
0 OHM
2.2
J
100
J
L504
L505,506
L507
L802
L803
L40-1021-33
L40-4705-34
L41-1585-09
L39-0477-05
L39-1487-05
SMALL FIXED INDUCTOR
SMALL FIXED INDUCTOR (47UH)
SMALL FIXED INDUCTOR
TOROIDAL COIL
TOROIDAL COIL
R81
R90
R101
R151
R201,202
RS14DB3A101J
R92-3574-05
R92-0679-05
R92-0679-05
R92-0679-05
FL-PROOF RS
RESISTOR
CHIP R
CHIP R
CHIP R
100
J
0.1
J
0 OHM
0 OHM
0 OHM
L39-1450-05
L33-0699-05
L40-4795-34
L39-1451-05
L33-0651-05
TOROIDAL COIL
CHOKE COIL
SMALL FIXED INDUCTOR (4.7UH)
TOROIDAL COIL
CHOKE COIL
R251,252
R301
R351
R401,402
R451,452
R92-0679-05
R92-0679-05
R92-0679-05
R92-0679-05
R92-0679-05
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
0 OHM
0 OHM
0 OHM
0 OHM
0 OHM
L39-1490-05
L33-0617-15
L92-0131-05
L39-1479-05
L39-1478-05
TOROIDAL COIL
CHOKE COIL
FERRITE CHIP
TOROIDAL COIL
TOROIDAL COIL
R501
R502
R503
R504
R505-507
RK73FB2A100J
R92-1279-05
R92-1305-05
RK73FB2A102J
RK73FB2A101J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
10
33
27
1.0K
100
J
J
J
J
J
1/10W
1W
1W
1/10W
1/10W
L821
L822,823
L33-0699-05
L40-3311-14
CHOKE COIL
SMALL FIXED INDUCTOR
R1
R2
R3
R4
R5
RK73FB2A470J
RK73FB2A331J
RK73FB2A180J
RK73FB2A470J
RK73FB2A331J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
47
330
18
47
330
J
J
J
J
J
1/10W
1/10W
1/10W
1/10W
1/10W
R508-511
R550
R551
R552
R553
RK73FB2A104J
RK73FB2A391J
RK73FB2A182J
RK73FB2A472J
R92-0670-05
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
100K
390
1.8K
4.7K
0 OHM
J
J
J
J
1/10W
1/10W
1/10W
1/10W
R6
R7
R9
R10
R11
RK73FB2A470J
RK73FB2A681J
RK73FB2A331J
RK73FB2A221J
RK73FB2A470J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
47
680
330
220
47
J
J
J
J
J
1/10W
1/10W
1/10W
1/10W
1/10W
R800
R803
R804
R805
R808
RS14DB3A101J
R92-1318-05
RK73EB2B391J
R92-2673-05
R92-2673-05
FL-PROOF RS
CHIP R
CHIP R
CHIP R
CHIP R
100
100
390
1.0
1.0
J
J
J
J
J
1W
1W
1/8W
1W
1W
R12
R13
R14
R15
R16
RK73FB2A100J
RK73FB2A820J
RK73FB2A220J
RK73FB2A681J
RK73FB2A331J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
10
82
22
680
330
J
J
J
J
J
1/10W
1/10W
1/10W
1/10W
1/10W
R809,810
R811,812
R813
R814
R816
R92-3511-05
R92-1240-05
RK73FB2A103J
RK73FB2A223J
R92-3558-05
CHIP R
CHIP R
CHIP R
CHIP R
METAL FILM R
8.2
10
10K
22K
100
J
J
J
J
J
1/2W
1/4W
1/10W
1/10W
10W
R17
R18
R19
R20
R21
RK73FB2A471J
RK73FB2A470J
RK73FB2A332J
RK73FB2A102J
RK73FB2A562J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
470
47
3.3K
1.0K
5.6K
J
J
J
J
J
1/10W
1/10W
1/10W
1/10W
1/10W
R92-3559-05
RK73FB2A100J
RK73FB2A4R7J
RK73EB2B1R0J
R92-0679-05
METAL FILM R
CHIP R
CHIP R
CHIP R
CHIP R
0.01
10
4.7
1.0
0 OHM
J
J
J
J
10W
1/10W
1/10W
1/8W
R22
R23,24
RK73FB2A102J
RK73FB2A470J
CHIP R
CHIP R
1.0K
47
J
J
1/10W
1/10W
RS14DB3F820J
R12-6730-05
R12-6737-05
R12-6737-05
R12-6744-05
FL-PROOF RS 82
J
TRIMMING POT. (220)
TRIMMING POT. (3.3K)
TRIMMING POT. (3.3K)
TRIMMING POT. (47K)
✽
✽
L804
L805,806
L807
L808
L809
L810
L814
L816,817
L818
L820
KH : TS-480HX (K)
EH : TS-480HX (E)
✽
✽
✽
KS : TS-480SAT (K)
ES : TS-480SAT (E)
R817
R822
R823
R824-829
R836-841
R842,843
VR1,2
VR3
VR801
VR802
✽
✽
✽
✽
✽
3W
1/4W
2W
1W
2W
3W
37
TS-480HX/480SAT
PARTS LIST
FINAL UNIT (X45-366X-XX)
DISPLAY UNIT (X54-3410-00)
Ref. No.
New
Address parts
Parts No.
Description
Destination
Ref. No.
New
Address parts
✽
Destination
Description
B30-2276-05
B30-2167-05
B30-2269-05
LED (R)
LED (GR)
LED (YELLOW)
C1
C2,3
C4
C5
C6,7
CK73GB1C104K
CK73GB1H103K
CK73GB1H102K
CK73GB1C104K
CK73GB1H103K
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
0.10UF
0.010UF
1000PF
0.10UF
0.010UF
K
K
K
K
K
RELAY
C8,9
C15
C16,17
C18
C19,20
CK73GB1H102K
C92-0041-05
CK73GB1C104K
C92-0041-05
CK73GB1C104K
CHIP C
CHIP-ELE
CHIP C
CHIP-ELE
CHIP C
1000PF
10UF
0.10UF
10UF
0.10UF
K
10WV
K
10WV
K
MA27-B
1SS355
ZSH5MA27
1SS355
1SS355
VARISTOR
DIODE
SURGE ABSORBER
DIODE
DIODE
C21,22
C23
C24
C25
C26
CC73GCH1H220J
CK73GB1H102K
CK73GB1H103K
C92-0698-05
C92-0004-05
CHIP C
CHIP C
CHIP C
ELECTRO
CHIP-TAN
22PF
1000PF
0.010UF
47UF
1.0UF
J
K
K
16WV
16WV
D151
D201
D251
D301
D351
1SS355
1SS355
1SS355
1SS355
1SS355
DIODE
DIODE
DIODE
DIODE
DIODE
C27,28
C29
C30
C31-33
C34-39
CC73GCH1H101J
CK73GB1C104K
CK73GB1H103K
CK73FB1C105K
CK73GB1H102K
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
100PF
0.10UF
0.010UF
1.0UF
1000PF
J
K
K
K
K
D401
D451
D501,502
D503,504
D505,506
1SS355
1SS355
1SS348
1SS355
DSA301LA
DIODE
DIODE
DIODE
DIODE
DIODE
C41-44
C45,46
C47
CK73GB1H102K
CK73FB1C105K
CK73GB1C104K
CHIP C
CHIP C
CHIP C
1000PF
1.0UF
0.10UF
K
K
K
✽
D802,803
D806
D807
IC1
IC2,3
MA27-B
ZSH5MA27
1SS348
TA7805F
TA7808F
VARISTOR
SURGE ABSORBER
DIODE
MOS IC
ANALOG IC
E29-1198-04
E40-3237-05
E40-5392-05
E40-3239-05
E40-5409-05
INTER CONNECTOR
PIN ASSY
PIN ASSY
PIN ASSY
PIN ASSY
✽
✽
E11-0482-05
E58-0506-05
3.5D PHONE JACK
MODULAR JACK
IC501
Q1
Q2
Q3
Q4,5
BU2099FV
2SK2596
2SK2595
2SC3421(Y)
2SC2782
MOS IC
FET
FET
TRANSISTOR
TRANSISTOR
SI7445DP
DTC114EKA
2SD1757K
FMA5A
RN47A5
FET
DIGITAL TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC3421(Y)
2SC2782
SI7445DP
DTC114EKA
157-153-53002
TRANSISTOR
TRANSISTOR
FET
DIGITAL TRANSISTOR
THERMISTOR
212-1021-05
INSULATING TUBE
W501-506
R92-0150-05
JUMPER REST
K101,102
K151,152
K201,202
K251,252
K301,302
S51-1420-05
S51-1420-05
S51-1420-05
S51-1420-05
S51-1420-05
RELAY
RELAY
RELAY
RELAY
RELAY
K351,352
K401,402
K451
K452
K501
S51-1420-05
S76-0401-05
S51-1420-05
S76-0401-05
S51-1429-05
RELAY
RELAY
RELAY
RELAY
RELAY
K502
S76-0424-05
D2,3
D4
D5
D6
D101
✽
Q6
Q7
Q8,9
Q501-505
Q506
Q803
Q804,805
Q806
Q807
TH1,2
✽
-
0 OHM
DISPLAY UNIT (X54-3410-00)
201
202
203
204
D1-4
D10-13
38
2G
2H
2G
2G
✽
✽
✽
✽
✽
B11-1801-03
B11-1802-14
B11-1803-04
B38-0879-05
B30-2270-05
ILLUMINATION GUIDE
FILTER
FILTER
LCD
LED (YELLOW)
✽
B30-2270-05
LED (YELLOW)
D14
D15
D16-36
Parts No.
205
CN2
CN3,4
CN5
CN6,7
2G
J1
J2
206
2G
✽
G13-1949-04
CUSHION
207
2G
✽
J21-8450-03
HARDWARE FIXTURE
L1,2
L3
L5-7
L8
X1
L40-1005-34
L92-0552-05
L92-0552-05
L33-0742-05
L77-1814-05
SMALL FIXED INDUCTOR (10UH)
FERRITE CHIP
FERRITE CHIP
SMALL FIXED INDUCTOR
CRYSTAL RESONATOR (11.0592MHZ)
CP1,2
CP3-5
R1
R2
R3,4
RK75GB1J103J
RK75GB1J473J
RK73GB1J472J
RK73FB2A121J
RK73GB1J472J
CHIP-COM
CHIP-COM
CHIP R
CHIP R
CHIP R
10K
47K
4.7K
120
4.7K
J
J
J
J
J
1/16W
1/16W
1/16W
1/10W
1/16W
R5
R6
R7
R8
R9,10
RK73GB1J473J
RK73FB2A390J
RK73FB2A5R6J
R92-0670-05
RK73GB1J472J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
47K
39
5.6
0 OHM
4.7K
J
J
J
1/16W
1/10W
1/10W
J
1/16W
R11,12
R13
R14
R15-19
R20,21
RK73FB2A560J
RK73GB1J472J
RK73GB1J473J
RK73GB1J102J
R92-1252-05
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
56
4.7K
47K
1.0K
0 OHM
J
J
J
J
J
1/10W
1/16W
1/16W
1/16W
1/16W
R22
R23
RK73GB1J103J
RK73FB2A271J
CHIP R
CHIP R
10K
270
J
J
1/16W
1/10W
KH : TS-480HX (K)
EH : TS-480HX (E)
KS : TS-480SAT (K)
ES : TS-480SAT (E)
TS-480HX/480SAT
PARTS LIST
DISPLAY UNIT (X54-3410-00)
TX-RX UNIT (X57-663X-XX)
Ref. No.
New
Address parts
Parts No.
Destination
Description
Ref. No.
New
Address parts
Parts No.
Destination
Description
R25
R26
R27
R28
R29
RK73FB2A221J
RK73GB1J473J
RK73GB1J102J
RK73GB1J473J
R92-1252-05
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
220
47K
1.0K
47K
0 OHM
J
J
J
J
J
1/10W
1/16W
1/16W
1/16W
1/16W
C19
C20,21
C22
C23
C24
CC73GCH1H470J
C92-0628-05
CK73GB1C473K
CK73GB1H102K
CK73GB1H472K
CHIP C
CHIP-TAN
CHIP C
CHIP C
CHIP C
47PF
10UF
0.047UF
1000PF
4700PF
J
10WV
K
K
K
R30-33
R34
R35
R36
R37
RK73GB1J473J
RK73FB2A152J
RK73FB2A181J
RK73FB2A331J
RK73FB2A181J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
47K
1.5K
180
330
180
J
J
J
J
J
1/16W
1/10W
1/10W
1/10W
1/10W
C25,26
C28
C29
C30
C31
CK73GB1C473K
CC73GCH1H390J
CK73GB1H103K
CK73GB1C473K
CK73GB1H103K
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
0.047UF
39PF
0.010UF
0.047UF
0.010UF
K
J
K
K
K
R38
R39
R40
R41,42
R43-45
RK73GB1J103J
RK73FB2A392J
RK73FB2A681J
RK73GB1J101J
RK73GB1J102J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
10K
3.9K
680
100
1.0K
J
J
J
J
J
1/16W
1/10W
1/10W
1/16W
1/16W
C32
C33
C34
C35,36
C37
CK73GB1C473K
CC73GCH1H040B
CC73GCH1H390J
CC73GCH1H331J
CK73GB1A105K
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
0.047UF
4.0PF
39PF
330PF
1.0UF
K
B
J
J
K
R47-50
R51-54
R55,56
R57
R58
RK73GB1J101J
RK73GB1J473J
R92-1205-05
RK73GB1J473J
RK73GB1J104J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
100
47K
120
47K
100K
J
J
J
J
J
1/16W
1/16W
1/4W
1/16W
1/16W
C38
C39
C40
C41
C42
CK73GB1C473K
CK73GB1H103K
CC73GCH1H221J
CC73GCH1H100D
CK73GB1C473K
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
0.047UF
0.010UF
220PF
10PF
0.047UF
K
K
J
D
K
R59,60
R62
R63
VR1
VR2
CHIP R
1.0K
J
CHIP R
0 OHM
CHIP R
1.2K
J
VARIABLE RESISTOR
VARIABLE RESISTOR
1/16W
✽
✽
RK73GB1J102J
R92-0670-05
RK73FB2A122J
R31-0645-05
R31-0644-05
C43
C44
C46
C47
C48
C92-0628-05
CK73GB1C473K
CK73GB1C473K
CK73GB1H103K
CK73GB1H102K
CHIP-TAN
CHIP C
CHIP C
CHIP C
CHIP C
10UF
0.047UF
0.047UF
0.010UF
1000PF
10WV
K
K
K
K
S1-33
S35
✽
✽
S70-0490-05
S70-0490-05
TACT SWITCH
TACT SWITCH
MA2S111
MA2S111
LC75823W
30622M8A-7N0GP
TC4S81F
DIODE
DIODE
MOS IC
MCU
MOS IC
C49-52
C53
C54,55
C56
C57
CK73GB1C473K
CK73GB1H103K
CK73GB1C473K
CK73GB1H391K
CK73GB1H471K
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
0.047UF
0.010UF
0.047UF
390PF
470PF
K
K
K
K
K
L78LR05B-FA
DTC114EE
2SA1162(Y)
MOS IC (SIP/5P/16)
DIGITAL TRANSISTOR
TRANSISTOR
C58
C59
C60
C61
C62
CK73GB1H102K
CC73GCH1H680J
CC73GCH1H330J
CC73GCH1H270J
CK73GB1H561K
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
1000PF
68PF
33PF
27PF
560PF
K
J
J
J
K
W02-3662-05
ENCODER
C63
C64,65
C66
C67
C68
CK73GB1H681K
CC73GCH1H820J
CC73GCH1H120J
CC73GCH1H271J
CC73GCH1H331J
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
680PF
82PF
12PF
270PF
330PF
K
J
J
J
J
C69
C70
C71
C72
C73
CK73GB1H391K
CC73GCH1H080B
CC73GCH1H271J
CK73GB1H102K
CC73GCH1H560J
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
390PF
8.0PF
270PF
1000PF
56PF
K
B
J
K
J
D5-9
D37
IC1,2
IC3
IC4,5
✽
IC6
Q1-6
Q7
✽
S34
1/10W
TX-RX UNIT (X57-663X-XX)
0-11 : KH 0-12 : KS 2-71 : EH 2-72 : ES
D621
B30-2001-05
LED (RE/MEN/8)
C1
C2
C3
C4
C5
CC73GCH1H080B
CC73GCH1H151J
CC73GCH1H390J
C92-0628-05
CK73GB1H472K
CHIP C
CHIP C
CHIP C
CHIP-TAN
CHIP C
8.0PF
150PF
39PF
10UF
4700PF
B
J
J
10WV
K
C74
C75
C76
C77
C78
CK73GB1C473K
CC73GCH1H120J
C92-0628-05
CC73GCH1H680J
CK73GB1H102K
CHIP C
CHIP C
CHIP-TAN
CHIP C
CHIP C
0.047UF
12PF
10UF
68PF
1000PF
K
J
10WV
J
K
C6
C8
C9
C10
C11
CK73GB1C473K
CK73GB1H103K
CC73GCH1H050B
CK73GB1C473K
CK73GB1H103K
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
0.047UF
0.010UF
5.0PF
0.047UF
0.010UF
K
K
B
K
K
C79
C80
C81
C83
C84
CK73GB1C473K
CK73GB1H102K
CC73GCH1H220J
CC73GCH1H180J
CC73GCH1H100D
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
0.047UF
1000PF
22PF
18PF
10PF
K
K
J
J
D
C12
C14,15
C16
C17
C18
CK73GB1C473K
CK73GB1C473K
CC73GCH1H470J
CK73GB1C473K
CK73GB1H103K
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
0.047UF
0.047UF
47PF
0.047UF
0.010UF
K
K
J
K
K
C85
C86
C87
C88
C89
CK73GB1C473K
CC73GCH1H470J
C92-0628-05
CK73GB1H472K
CK73GB1H102K
CHIP C
CHIP C
CHIP-TAN
CHIP C
CHIP C
0.047UF
47PF
10UF
4700PF
1000PF
K
J
10WV
K
K
KH : TS-480HX (K)
EH : TS-480HX (E)
KS : TS-480SAT (K)
ES : TS-480SAT (E)
39
TS-480HX/480SAT
PARTS LIST
TX-RX UNIT (X57-663X-XX)
Ref. No.
New
Address parts
Parts No.
Destination
Description
Ref. No.
New
Address parts
Parts No.
Destination
Description
C90
C91
C92
C93
C94
CC73GCH1H120J
CK73GB1H472K
CC73GCH1H240J
CC73GCH1H220J
C92-0001-05
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
12PF
4700PF
24PF
22PF
0.1UF
J
K
J
J
35WV
C238
C239-241
C242
C243
C244,245
C92-0562-05
CK73GB1C104K
C92-0560-05
CK73GB1H103K
CK73GB1C104K
CHIP-ELE
CHIP C
CHIP-TAN
CHIP C
CHIP C
330UF
0.10UF
10UF
0.010UF
0.10UF
6.3WV
K
6.3WV
K
K
C95
C96,97
C98
C99
C100
CK73GB1H472K
CK73GB1H102K
CK73GB1C104K
C92-0628-05
CK73GB1H472K
CHIP C
CHIP C
CHIP C
CHIP-TAN
CHIP C
4700PF
1000PF
0.10UF
10UF
4700PF
K
K
K
10WV
K
C246
C247
C248
C249
C250
C92-0562-05
C92-0560-05
CK73GB1C104K
CK73GB1H822K
CK73GB1H102K
CHIP-ELE
CHIP-TAN
CHIP C
CHIP C
CHIP C
330UF
10UF
0.10UF
8200PF
1000PF
6.3WV
6.3WV
K
K
K
C101
C102
C103
C104
C105
CK73GB1H102K
CK73GB1C333J
CK73GB1H102K
CK73GB1H472K
C92-0041-05
CHIP C
CHIP C
CHIP C
CHIP C
CHIP-ELE
1000PF
0.033UF
1000PF
4700PF
10UF
K
J
K
K
10WV
C251
C252
C253
C254
C255
CK73GB1A105K
C92-0041-05
CK73GB1C104K
C92-0041-05
CK73GB1C104K
CHIP C
CHIP-ELE
CHIP C
CHIP-ELE
CHIP C
1.0UF
10UF
0.10UF
10UF
0.10UF
K
10WV
K
10WV
K
C106
C107
C108
C115
C116
C92-0653-05
CK73GB1H472K
C92-0628-05
CK73GB1C223K
CK73GB1H103K
CHIP-TAN
CHIP C
CHIP-TAN
CHIP C
CHIP C
0.68UF
4700PF
10UF
0.022UF
0.010UF
10WV
K
10WV
K
K
C256
C257
C258
C259
C260
CK73GB1H103K
CK73GB1C104K
C92-0560-05
CK73GB1H103K
C92-0560-05
CHIP C
CHIP C
CHIP-TAN
CHIP C
CHIP-TAN
0.010UF
0.10UF
10UF
0.010UF
10UF
K
K
6.3WV
K
6.3WV
C117
C118,119
C120
C121
C122,123
CK73GB1C104K
CK73GB1H103K
CC73GCH1H101J
CC73GCH1H151J
CK73GB1H103K
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
0.10UF
0.010UF
100PF
150PF
0.010UF
K
K
J
J
K
C261
C262
C263
C264
C265
CK73GB1C104K
C92-0560-05
CK73GB1A105K
CK73GB1H822K
CK73GB1H102K
CHIP C
CHIP-TAN
CHIP C
CHIP C
CHIP C
0.10UF
10UF
1.0UF
8200PF
1000PF
K
6.3WV
K
K
K
C124
C131-133
C134,135
C136-138
C139
CK73GB1C473K
CK73GB1H102K
CK73GB1H103K
CK73GB1H102K
CK73GB1C104K
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
0.047UF
1000PF
0.010UF
1000PF
0.10UF
K
K
K
K
K
C266
C267
C268
C269
C270
CK73GB1H103K
CK73GB1A105K
CK73GB1H103K
CK73GB1C104K
CK73GB1H103K
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
0.010UF
1.0UF
0.010UF
0.10UF
0.010UF
K
K
K
K
K
C140
C141
C142
C143
C144
CK45FE2H222P
CK73GB1A105K
CK73GB1H102K
CK73GB1A105K
CK73GB1H103K
CERAMIC
CHIP C
CHIP C
CHIP C
CHIP C
2200PF
1.0UF
1000PF
1.0UF
0.010UF
P
K
K
K
K
C271
C272
C273
C274
C275
C92-0560-05
CK73GB1A105K
CK73GB1H272K
C92-0560-05
CK73GB1H471K
CHIP-TAN
CHIP C
CHIP C
CHIP-TAN
CHIP C
10UF
1.0UF
2700PF
10UF
470PF
6.3WV
K
K
6.3WV
K
C145
C146,147
C148
C149
C150,151
C92-0628-05
CK73GB1A105K
C92-0628-05
CK73GB1A105K
CK73GB1H103K
CHIP-TAN
CHIP C
CHIP-TAN
CHIP C
CHIP C
10UF
1.0UF
10UF
1.0UF
0.010UF
10WV
K
10WV
K
K
C276
C279
C280
C281
C282,283
CK73GB1A105K
C92-0560-05
CK73GB1C104K
C92-0048-05
CK73GB1C104K
CHIP C
CHIP-TAN
CHIP C
ELECTRO
CHIP C
1.0UF
10UF
0.10UF
100UF
0.10UF
K
6.3WV
K
6.3WV
K
C152
C153
C171-175
C176-187
C188
CK73FB1E104K
CK73GB1H102K
CC73GCH1H101J
CK73GB1H102K
CK73GB1C104K
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
0.10UF
1000PF
100PF
1000PF
0.10UF
K
K
J
K
K
C284,285
C286
C287
C288
C289
CK73GB1H103K
C92-0560-05
C92-0048-05
CK73GB1C104K
CK73GB1H103K
CHIP C
CHIP-TAN
ELECTRO
CHIP C
CHIP C
0.010UF
10UF
100UF
0.10UF
0.010UF
K
6.3WV
6.3WV
K
K
C189-194
C196,197
C201,202
C203-206
C207
CC73GCH1H101J
CK73GB1H102K
CK73GB1H102K
CK73FB1C105K
CK73GB1H102K
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
100PF
1000PF
1000PF
1.0UF
1000PF
J
K
K
K
K
C290
C291
C292
C293
C294
CK73GB1A105K
CK73GB1H471K
CK73GB1A105K
CK73GB1H272K
CK73GB1H103K
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
1.0UF
470PF
1.0UF
2700PF
0.010UF
K
K
K
K
K
C208,209
C210-212
C214
C217,218
C220,221
CK73GB1H103K
CK73GB1H102K
C90-4112-05
CK73GB1H103K
CK73FB1C105K
CHIP C
CHIP C
ELECTRO
CHIP C
CHIP C
0.010UF
1000PF
100UF
0.010UF
1.0UF
K
K
16WV
K
K
C295,296
C297
C298,299
C300
C301,302
CK73GB1C104K
CK73GB1H103K
CK73GB1C104K
CK73GB1H103K
CK73GB1C104K
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
0.10UF
0.010UF
0.10UF
0.010UF
0.10UF
K
K
K
K
K
CK73GB1H102K
CK73GB1H103K
CC73GCH1H220J
CK73GB1H103K
CK73GB1H103K
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
1000PF
0.010UF
22PF
0.010UF
0.010UF
K
K
J
K
K
C303
C304,305
C306
C307
C308
C92-0560-05
CK73GB1E223K
CK73GB1H103K
CK73GB1C104K
CK73GB1H102K
CHIP-TAN
CHIP C
CHIP C
CHIP C
CHIP C
10UF
0.022UF
0.010UF
0.10UF
1000PF
6.3WV
K
K
K
K
C222,223
C224-226
C227,228
C229,230
C232-237
40
✽
KH : TS-480HX (K)
EH : TS-480HX (E)
KS : TS-480SAT (K)
ES : TS-480SAT (E)
TS-480HX/480SAT
PARTS LIST
TX-RX UNIT (X57-663X-XX)
Ref. No.
New
Address parts
Parts No.
Destination
Description
Ref. No.
New
Address parts
Parts No.
Destination
Description
C309,310
C311
C312
C313
C314
C92-0560-05
C92-0004-05
CK73GB1C104K
CK73GB1H103K
CC73GCH1H101J
CHIP-TAN
CHIP-TAN
CHIP C
CHIP C
CHIP C
10UF
1.0UF
0.10UF
0.010UF
100PF
6.3WV
16WV
K
K
J
C474
C476
C477
C478
C479
CK73GB1C473K
CK73GB1H472K
CC73GCH1H101J
CK73GB1H102K
CC73GCH1H100D
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
0.047UF
4700PF
100PF
1000PF
10PF
K
K
J
K
D
C315,316
C317,318
C320
C321
C322
CK73GB1H103K
CC73GCH1H270J
C92-0560-05
CK73GB1C104K
CK73GB1A105K
CHIP C
CHIP C
CHIP-TAN
CHIP C
CHIP C
0.010UF
27PF
10UF
0.10UF
1.0UF
K
J
6.3WV
K
K
C480
C481
C482
C483
C484
CK73GB1A105K
CC73GCH1H270J
CC73GCH1H220J
CC73GCH1H120J
CC73GCH1H150J
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
1.0UF
27PF
22PF
12PF
15PF
K
J
J
J
J
C323
C324
C325
C326
C327
CK73GB1H103K
CK73GB1C104K
CK73FB1C105K
CK73GB1A105K
CK73GB1H103K
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
0.010UF
0.10UF
1.0UF
1.0UF
0.010UF
K
K
K
K
K
C485
C486
C487
C488
C501
CC73GCH1H270J
CC73GCH1H100D
CK73GB1H103K
CK73GB1H102K
CK73GB1H103K
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
27PF
10PF
0.010UF
1000PF
0.010UF
J
D
K
K
K
C328
C329
C351-356
C357-359
C360
CK73GB1A105K
CK73GB1H103K
CK73GB1H103K
CC73GCH1H101J
CK73GB1H103K
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
1.0UF
0.010UF
0.010UF
100PF
0.010UF
K
K
K
J
K
C502
C503
C504,505
C506
C507
CC73GCH1H100D
CC73GCH1H020B
CK73GB1H103K
CC73GCH1H470J
CK73GB1H103K
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
10PF
2.0PF
0.010UF
47PF
0.010UF
D
B
K
J
K
C362
C363-366
C367
C368-374
C375-379
CK73GB1C104K
CK73GB1H103K
CK73GB1H102K
CK73GB1C104K
CC73GCH1H101J
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
0.10UF
0.010UF
1000PF
0.10UF
100PF
K
K
K
K
J
C508
C509
C511
C512
C514,515
CC73GCH1H470J
CK73GB1H103K
C92-0003-05
CK73GB1H103K
CK73GB1H103K
CHIP C
CHIP C
CHIP-TAN
CHIP C
CHIP C
47PF
0.010UF
0.47UF
0.010UF
0.010UF
J
K
25WV
K
K
C382
C383,384
C385
C386
C387
CK73GB1H103K
CK73GB1H102K
CK73GB1A105K
CC73GCH1H101J
CK73GB1A105K
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
0.010UF
1000PF
1.0UF
100PF
1.0UF
K
K
K
J
K
C517,518
C519
C521
C522
C523,524
CK73GB1H103K
CK73GB1H102K
CK73GB1A105K
CC73GCH1H100D
CK73GB1H103K
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
0.010UF
1000PF
1.0UF
10PF
0.010UF
K
K
K
D
K
C388
C389
C390-393
C394,395
C397-404
CC73GCH1H101J
C92-0560-05
CC73GCH1H101J
CK73GB1H102K
CK73GB1H102K
CHIP C
CHIP-TAN
CHIP C
CHIP C
CHIP C
100PF
10UF
100PF
1000PF
1000PF
J
6.3WV
J
K
K
C525
C526
C527
C528
C529
CK73GB1H102K
C92-0628-05
CE04EW1E470M
CK73GB1H103K
CC73GCH1H470J
CHIP C
CHIP-TAN
ELECTRO
CHIP C
CHIP C
1000PF
10UF
47UF
0.010UF
47PF
K
10WV
25WV
K
J
C405-407
C408-410
C411,412
C413
C414
CC73GCH1H101J
CK73GB1C104K
CK73GB1H103K
CK73GB1H102K
C92-0041-05
CHIP C
CHIP C
CHIP C
CHIP C
CHIP-ELE
100PF
0.10UF
0.010UF
1000PF
10UF
J
K
K
K
10WV
C551,552
C553
C554
C555,556
C557
CK73GB1C104K
CC73GCH1H270J
CK73GB1C104K
CC73GCH1H271J
CC73GCH1H391J
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
0.10UF
27PF
0.10UF
270PF
390PF
K
J
K
J
J
C415-417
C418,419
C420
C451
C452
CK73GB1H102K
CK73GB1C104K
C90-4114-05
CC73GCH1H121J
CC73GCH1H820J
CHIP C
CHIP C
ELECTRO
CHIP C
CHIP C
1000PF
0.10UF
470UF
120PF
82PF
K
K
16WV
J
J
C558
C559
C560
C561,562
C563
CK73GB1H103K
C92-0628-05
CK73GB1C104K
CK73GB1H103K
CK73GB1C104K
CHIP C
CHIP-TAN
CHIP C
CHIP C
CHIP C
0.010UF
10UF
0.10UF
0.010UF
0.10UF
K
10WV
K
K
K
C453
C455,456
C457,458
C459
C460
CC73GCH1H060B
CK73GB1C473K
CK73GB1A105K
CC73GCH1H180J
CC73GCH1H120J
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
6.0PF
0.047UF
1.0UF
18PF
12PF
B
K
K
J
J
C564-566
C567
C568-570
C571
C572
CK73GB1H103K
CC73GCH1H390J
CK73GB1H103K
CK73GB1H102K
CC73GCH1H050B
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
0.010UF
39PF
0.010UF
1000PF
5.0PF
K
J
K
K
B
C461
C462
C463,464
C465
C466,467
CC73GCH1H330J
CC73GCH1H270J
CC73GCH1H150J
CK73GB1H103K
CC73GCH1H100D
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
33PF
27PF
15PF
0.010UF
10PF
J
J
J
K
D
C573
C574
C575
C576,577
C579
CC73GCH1H221J
CK73GB1H103K
CC73GCH1H390J
CK73GB1H103K
CC73GCH1H150J
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
220PF
0.010UF
39PF
0.010UF
15PF
J
K
J
K
J
C468,469
C470
C471
C472
C473
CK73GB1H103K
CK73GB1H472K
CK73GB1H102K
CK73GB1H472K
CC73GCH1H470J
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
0.010UF
4700PF
1000PF
4700PF
47PF
K
K
K
K
J
C581
C582
C583
C584
C585,586
CC73GCH1H470J
CK73GB1H102K
CC73GCH1H030B
CC73GCH1H470J
CK73GB1C104K
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
47PF
1000PF
3.0PF
47PF
0.10UF
J
K
B
J
K
KH : TS-480HX (K)
EH : TS-480HX (E)
✽
KS : TS-480SAT (K)
ES : TS-480SAT (E)
41
TS-480HX/480SAT
PARTS LIST
TX-RX UNIT (X57-663X-XX)
Ref. No.
New
Address parts
Parts No.
Destination
Description
Ref. No.
C587
C588
C589
C590
C591
CC73GCH1H221J
CK73GB1C104K
CC73GCH1H101J
CK73GB1C104K
C92-0665-05
CHIP C
CHIP C
CHIP C
CHIP C
TANTAL
220PF
0.10UF
100PF
0.10UF
100UF
J
K
J
K
6.3WV
C755
C756
C757
C758
C759
C592
C593
C594-596
C597
C599
CK73GB1H102K
CK73GB1H103K
CK73GB1A105K
CK73GB1H103K
CK73GB1C104K
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
1000PF
0.010UF
1.0UF
0.010UF
0.10UF
K
K
K
K
K
C600,601
C602,603
C604
C622-624
C625
CK73GB1A105K
CK73GB1C104K
CC73GCH1H220J
CK73GB1H103K
CK73GB1C104K
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
1.0UF
0.10UF
22PF
0.010UF
0.10UF
C626
C627,628
C629-631
C632
C633,634
CK73GB1H102K
CK73GB1H103K
CK73GB1C104K
C92-0694-05
CK73GB1C104K
CHIP C
CHIP C
CHIP C
TANTAL
CHIP C
C635
C636-638
C639
C640,641
C642
C92-0694-05
CK73GB1C104K
C92-0694-05
C92-0560-05
C92-0694-05
C643
C644
C681
C682
C685
New
Address parts
Parts No.
Destination
Description
CE04EW1E4R7M
C90-4112-05
CK73FB1E104K
CK73GB1H103K
CK73FB1E104K
ELECTRO
ELECTRO
CHIP C
CHIP C
CHIP C
4.7UF
100UF
0.10UF
0.010UF
0.10UF
25WV
16WV
K
K
K
C760
C761,762
C763,764
C801-804
C805,806
CK73FB1C105K
CK73FB1E104K
CK73GB1A105K
CK73GB1H102K
CK73GB1C104K
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
1.0UF
0.10UF
1.0UF
1000PF
0.10UF
K
K
K
K
K
K
K
J
K
K
C807
C808
C809
C810
C811
CK73GB1H102K
C92-0628-05
CK73GB1H103K
CC73GCH1H330J
CK73GB1H103K
CHIP C
CHIP-TAN
CHIP C
CHIP C
CHIP C
1000PF
10UF
0.010UF
33PF
0.010UF
K
10WV
K
J
K
1000PF
0.010UF
0.10UF
10UF
0.10UF
K
K
K
16WV
K
C812
C813
C814
C817,818
C821
C92-0560-05
CK73GB1H103K
CC73GCH1H101J
CK73GB1H103K
C92-0628-05
CHIP-TAN
CHIP C
CHIP C
CHIP C
CHIP-TAN
10UF
0.010UF
100PF
0.010UF
10UF
6.3WV
K
J
K
10WV
TANTAL
CHIP C
TANTAL
CHIP-TAN
TANTAL
10UF
0.10UF
10UF
10UF
10UF
16WV
K
16WV
6.3WV
16WV
C822
C901-904
C905
C906
C907
CC73GCH1H150J
CK73GB1H103K
CC73GCH1H101J
CK73GB1H103K
CC73GCH1H220J
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
15PF
0.010UF
100PF
0.010UF
22PF
J
K
J
K
J
CK73GB1C104K
CK73GB1A105K
C92-0005-05
C92-0628-05
CK73GB1H103K
CHIP C
CHIP C
CHIP-TAN
CHIP-TAN
CHIP C
0.10UF
1.0UF
2.2UF
10UF
0.010UF
K
K
6.3WV
10WV
K
C908,909
C911
C913-916
C923,924
C925
CK73GB1H103K
CK73GB1H102K
CK73GB1H103K
CK73GB1H103K
CC73GCH1H050B
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
0.010UF
1000PF
0.010UF
0.010UF
5.0PF
K
K
K
K
B
C686
C687
C688
C689
C690
C92-0002-05
CK73GB1H103K
C92-0004-05
C92-0560-05
C92-0507-05
CHIP-TAN
CHIP C
CHIP-TAN
CHIP-TAN
CHIP-TAN
0.22UF
0.010UF
1.0UF
10UF
4.7UF
35WV
K
16WV
6.3WV
6.3WV
C926
C927
C928
C931-938
C943
CK73GB1H103K
CC73GCH1H101J
CC73GCH1H560J
CK73GB1H103K
CC73GCH1H200J
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
0.010UF
100PF
56PF
0.010UF
20PF
K
J
J
K
J
C691
C692
C693
C694
C695
CK73GB1H102K
CK73GB1C104K
CK73GB1H471K
CK73GB1H103K
C92-0561-05
CHIP C
CHIP C
CHIP C
CHIP C
CHIP-ELE
1000PF
0.10UF
470PF
0.010UF
22UF
K
K
K
K
16WV
C944
C949-959
C960,961
C962
C972
CK73GB1H103K
CK73GB1H103K
CC73GCH1H100D
CC73GCH1H050B
CK73GB1H103K
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
0.010UF
0.010UF
10PF
5.0PF
0.010UF
K
K
D
B
K
C696
C697
C698
C699
C700
CK73GB1C104K
CK73GB1C473K
CK73GB1H102K
CK73GB1A105K
CK73GB1H103K
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
0.10UF
0.047UF
1000PF
1.0UF
0.010UF
K
K
K
K
K
C973
C974
C975
C977
C978-980
CE04EW1C100M
CK73GB1C473K
CK73GB1H103K
CC73GCH1H100D
CK73GB1H103K
ELECTRO
CHIP C
CHIP C
CHIP C
CHIP C
10UF
0.047UF
0.010UF
10PF
0.010UF
16WV
K
K
D
K
C701-705
C706,707
C731,732
C733-736
C737
CK73GB1C104K
CK73GB1A105K
CK73GB1H103K
CK73GB1C104K
CK73GB1H103K
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
0.10UF
1.0UF
0.010UF
0.10UF
0.010UF
K
K
K
K
K
C981
C982,983
C984
C985
TC1
CK73GB1C473K
CC73GCH1H050B
CK73GB1H103K
CC73GCH1H470J
C05-0384-05
CHIP C
0.047UF K
CHIP C
5.0PF
B
CHIP C
0.010UF K
CHIP C
47PF
J
CERAMIC TRIMMER CAP (10PF)
C738,739
C741,742
C744
C745,746
C747
CHIP C
CHIP C
ELECTRO
CHIP C
CHIP C
0.10UF
1.0UF
220UF
1.0UF
0.010UF
K
K
16WV
K
K
TC451-453
C05-0384-05
CERAMIC TRIMMER CAP (10PF)
✽
CK73GB1C104K
CK73GB1A105K
C90-4113-05
CK73GB1A105K
CK73GB1H103K
CHIP C
ELECTRO
ELECTRO
CHIP C
ELECTRO
0.010UF
47UF
470UF
0.10UF
470UF
K
16WV
16WV
K
16WV
E04-0191-05
E04-0191-05
E40-5978-05
E40-3252-05
E40-5758-05
PIN SOCKET
PIN SOCKET
FLAT CABLE CONNECTOR
PIN ASSY
FLAT CABLE CONNECTOR
✽
CK73GB1H103K
CE04EW1C470M
C90-4111-05
CK73FB1E104K
C90-4114-05
CN1
CN3
CN359
CN369
CN375
E40-3247-05
E40-6357-05
E40-5978-05
PIN ASSY
PIN ASSY
FLAT CABLE CONNECTOR
C749
C750,751
C752
C753
C754
42
✽
CN382
CN390
CN403
✽
✽
KH : TS-480HX (K)
EH : TS-480HX (E)
KS : TS-480SAT (K)
ES : TS-480SAT (E)
TS-480HX/480SAT
PARTS LIST
TX-RX UNIT (X57-663X-XX)
Ref. No.
New
Address parts
Parts No.
Description
Destination
Ref. No.
E04-0191-05
E40-6267-05
E40-6273-05
E40-6266-05
E40-6272-05
PIN SOCKET
PIN ASSY
PIN ASSY
PIN ASSY
PIN ASSY
L218-220
L221
L222
L223
L226
✽
✽
E56-0411-05
E56-0405-05
E58-0435-05
E58-0506-05
E58-0507-05
DIN SOCKET
DIN SOCKET
SUB SOCKET (D)
MODULAR JACK
MODULAR JACK
L227
L228,229
L351
L352-357
L358
✽
E11-0414-05
E37-1058-05
3.5D PHONE JACK (3P)
LEAD WIRE WITH CONNECTOR
F10-2458-04
F10-2459-04
F20-3320-04
SHIELDING CASE
SHIELDING CASE
INSULATING SHEET
L361-363
L364
L365,366
L451,452
L453,454
CF1
CF551
L1
L3
L4
L72-0343-05
L72-0372-05
L40-1005-34
L40-1595-34
L40-2295-34
CERAMIC FILTER
CERAMIC FILTER
SMALL FIXED INDUCTOR (10UH)
SMALL FIXED INDUCTOR (1.5UH)
SMALL FIXED INDUCTOR (2.2UH)
L5
L6
L7
L8
L9
L40-1005-34
L34-4345-05
L39-1480-05
L40-1005-34
L34-4345-05
SMALL FIXED INDUCTOR (10UH)
COIL
TOROIDAL COIL
SMALL FIXED INDUCTOR (10UH)
COIL
L10
L11
L12,13
L14
L15,16
L40-1015-34
L40-2295-34
L40-1005-34
L40-1085-34
L40-8285-34
SMALL FIXED INDUCTOR (100UH)
SMALL FIXED INDUCTOR (2.2UH)
SMALL FIXED INDUCTOR (10UH)
SMALL FIXED INDUCTOR (100NH)
SMALL FIXED INDUCTOR (820NH)
L18
L19
L20
L21
L22
L40-4785-34
L40-5685-34
L40-6885-34
L40-2275-34
L40-8285-34
SMALL FIXED INDUCTOR (470NH)
SMALL FIXED INDUCTOR (560NH)
SMALL FIXED INDUCTOR (680NH)
SMALL FIXED INDUCTOR (22NH)
SMALL FIXED INDUCTOR (820NH)
L40-8275-34
L40-2275-34
L40-4785-34
L40-8275-34
L40-1005-34
SMALL FIXED INDUCTOR (82NH)
SMALL FIXED INDUCTOR (22NH)
SMALL FIXED INDUCTOR (470NH)
SMALL FIXED INDUCTOR (82NH)
SMALL FIXED INDUCTOR (10UH)
L28
L29
L30
L31
L33
L40-1085-34
L40-1015-34
L40-3375-34
L40-3975-34
L40-1005-34
SMALL FIXED INDUCTOR (100NH)
SMALL FIXED INDUCTOR (100UH)
SMALL FIXED INDUCTOR (33NH)
SMALL FIXED INDUCTOR (39NH)
SMALL FIXED INDUCTOR (10UH)
L34
L35
L132
L133
L134
L40-1095-34
L40-1005-34
L40-1005-34
L40-1015-34
L40-1095-34
SMALL FIXED INDUCTOR (1UH)
SMALL FIXED INDUCTOR (10UH)
SMALL FIXED INDUCTOR (10UH)
SMALL FIXED INDUCTOR (100UH)
SMALL FIXED INDUCTOR (1UH)
L171,172
L174
L175
L201
L202-205
L40-1005-34
L92-0149-05
L40-1015-34
L40-3395-34
L40-1015-34
SMALL FIXED INDUCTOR (10UH)
FERRITE CHIP
SMALL FIXED INDUCTOR (100UH)
SMALL FIXED INDUCTOR (3.3UH)
SMALL FIXED INDUCTOR (100UH)
L207-210
L211
L212
L217
L40-3395-34
L40-4705-34
L40-1015-34
L41-1005-27
SMALL FIXED INDUCTOR (3.3UH)
SMALL FIXED INDUCTOR (47UH)
SMALL FIXED INDUCTOR (100UH)
SMALL FIXED INDUCTOR
CN501
CN554
CN555
CN901
CN971
J131
J132
J201
J202
J351
J731
W501
-
L23
L24
L25
L26
L27
KH : TS-480HX (K)
EH : TS-480HX (E)
✽
✽
✽
✽
✽
✽
✽
✽
✽
✽
✽
KS : TS-480SAT (K)
ES : TS-480SAT (E)
New
Address parts
Parts No.
Destination
Description
L40-1015-34
L92-0149-05
L41-1005-27
L40-1005-34
L40-1015-34
SMALL FIXED INDUCTOR (100UH)
FERRITE CHIP
SMALL FIXED INDUCTOR
SMALL FIXED INDUCTOR (10UH)
SMALL FIXED INDUCTOR (100UH)
L41-1005-27
L40-1015-34
L40-1005-34
L92-0149-05
L40-1005-34
SMALL FIXED INDUCTOR
SMALL FIXED INDUCTOR (100UH)
SMALL FIXED INDUCTOR (10UH)
FERRITE CHIP
SMALL FIXED INDUCTOR (10UH)
L40-1005-34
L41-1015-27
L40-1005-34
L41-2295-09
L41-1005-08
SMALL FIXED INDUCTOR (10UH)
SMALL FIXED INDUCTOR
SMALL FIXED INDUCTOR (10UH)
SMALL FIXED INDUCTOR
SMALL FIXED INDUCTOR
L41-2288-09
L41-1888-09
L40-2205-34
L41-2295-09
L41-1005-08
SMALL FIXED INDUCTOR
SMALL FIXED INDUCTOR
SMALL FIXED INDUCTOR (22UH)
SMALL FIXED INDUCTOR
SMALL FIXED INDUCTOR
L40-1095-34
L41-1588-09
L40-2205-34
L40-3975-34
L40-1085-34
SMALL FIXED INDUCTOR (1UH)
SMALL FIXED INDUCTOR
SMALL FIXED INDUCTOR (22UH)
SMALL FIXED INDUCTOR (39NH)
SMALL FIXED INDUCTOR (100NH)
L502
L503
L504
L505
L506,507
L40-2285-34
L33-0695-05
L40-4795-34
L40-4705-34
L34-4401-05
SMALL FIXED INDUCTOR (220NH)
SMALL FIXED INDUCTOR
SMALL FIXED INDUCTOR (4.7UH)
SMALL FIXED INDUCTOR (47UH)
COIL
L551
L552
L553,554
L556
L558
L34-4459-05
L40-1085-34
L34-4710-05
L40-3305-34
L40-1015-34
COIL
SMALL FIXED INDUCTOR (100NH)
COIL
SMALL FIXED INDUCTOR (33UH)
SMALL FIXED INDUCTOR (100UH)
L622,623
L624-626
L682
L801
L901,902
L40-1005-34
L40-1015-34
L40-1015-34
L40-1015-34
L40-1015-34
SMALL FIXED INDUCTOR (10UH)
SMALL FIXED INDUCTOR (100UH)
SMALL FIXED INDUCTOR (100UH)
SMALL FIXED INDUCTOR (100UH)
SMALL FIXED INDUCTOR (100UH)
L903
L904
L905,906
L908,909
L910
L40-4795-34
L40-1005-34
L40-4705-34
L40-1015-34
L40-3395-34
SMALL FIXED INDUCTOR (4.7UH)
SMALL FIXED INDUCTOR (10UH)
SMALL FIXED INDUCTOR (47UH)
SMALL FIXED INDUCTOR (100UH)
SMALL FIXED INDUCTOR (3.3UH)
L931-936
L971,972
L974,975
L976
X1
L40-1015-34
L40-1015-34
L40-4705-34
L40-1001-37
L77-1906-05
SMALL FIXED INDUCTOR (100UH)
SMALL FIXED INDUCTOR (100UH)
SMALL FIXED INDUCTOR (47UH)
SMALL FIXED INDUCTOR (10UH)
CRYSTAL RESONATOR (15.6MHZ)
L77-1907-05
L77-1920-05
L71-0433-15
L71-0604-05
CRYSTAL RESONATOR (22.1184MHZ)
CRYSTAL RESONATOR (12.288MHZ)
MCF (10.695MHZ)
CRYSTAL FILTER (10.695MHZ)
RK75GA1J473J
RK75GB1J473J
RK75GA1J473J
RK75GB1J102J
RK75GA1J101J
CHIP-COM
CHIP-COM
CHIP-COM
CHIP-COM
CHIP-COM
L455
L456
L457,458
L461
L462
L463
L464
L465
L466
L501
X201
X202
XF931
XF932
CP201
CP202
CP204
CP205-207
CP208
✽
✽
✽
✽
✽
✽
✽
✽
✽
✽
✽
✽
✽
47K
47K
47K
1.0K
100
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
43
TS-480HX/480SAT
PARTS LIST
TX-RX UNIT (X57-663X-XX)
Ref. No.
New
Address parts
Parts No.
Destination
Description
Ref. No.
New
Address parts
Parts No.
Destination
Description
CP209,210
CP211
CP212
CP213
CP214
RK75GB1J101J
RK75GA1J101J
RK75GB1J102J
RK75GA1J473J
RK75GA1J101J
CHIP-COM
CHIP-COM
CHIP-COM
CHIP-COM
CHIP-COM
100
100
1.0K
47K
100
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R46
R47
R48,49
R51
R52
RK73GB1J470J
RK73GB1J271J
RK73GB1J104J
RK73GB1J470J
RK73GB1J102J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
47
270
100K
47
1.0K
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
CP215
CP216,217
CP219
CP220-222
CP223
RK75GB1J101J
RK75GB1J473J
RK75GA1J473J
RK75GB1J101J
RK75GA1J101J
CHIP-COM
CHIP-COM
CHIP-COM
CHIP-COM
CHIP-COM
100
47K
47K
100
100
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R53
R54
R55
R56
R57
RK73GB1J101J
RK73GB1J391J
RK73GB1J153J
RK73GB1J682J
RK73GB1J331J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
100
390
15K
6.8K
330
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
CP224,225
CP226
CP228
CP230
CP231-233
RK75GB1J101J
RK75GA1J102J
RK75GB1J473J
RK75GA1J473J
RK75GB1J101J
CHIP-COM
CHIP-COM
CHIP-COM
CHIP-COM
CHIP-COM
100
1.0K
47K
47K
100
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R58,59
R60
R61
R63
R64
RK73GB1J470J
RK73GB1J271J
RK73GB1J470J
RK73GB1J271J
RK73GB1J391J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
47
270
47
270
390
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
CP351
CP731,732
CP802
R1
R2
RK75GB1J101J
RK75GB1J103J
RK75GB1J473J
RK73GB1J103J
RK73GB1J223J
CHIP-COM
CHIP-COM
CHIP-COM
CHIP R
CHIP R
100
10K
47K
10K
22K
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R65
R66
R67
R68
R69,70
RK73GB1J180J
RK73GB1J271J
RK73GB1J102J
RK73GB1J472J
RK73GB1J102J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
18
270
1.0K
4.7K
1.0K
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R3
R4
R5
R6
R7
RK73GB1J100J
RK73GB1J101J
RK73GB1J222J
RK73GB1J823J
RK73GB1J331J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
10
100
2.2K
82K
330
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R71
R72
R73
R74
R75
RK73GB1J122J
RK73GB1J471J
RK73GB1J102J
RK73GB1J471J
RK73GB1J153J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
1.2K
470
1.0K
470
15K
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R8
R10
R11
R12
R13
RK73GB1J224J
RK73GB1J392J
RK73GB1J100J
RK73GB1J101J
RK73GB1J822J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
220K
3.9K
10
100
8.2K
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R76
R77
R78
R79
R80
RK73GB1J682J
RK73GB1J470J
RK73GB1J101J
RK73GB1J820J
RK73GB1J103J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
6.8K
47
100
82
10K
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R14
R15
R16
R17
R18
RK73GB1J153J
RK73GB1J470J
RK73GB1J102J
RK73GB1J391J
RK73GB1J100J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
15K
47
1.0K
390
10
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R81
R82
R83
R84
R85
RK73GB1J271J
RK73GB1J180J
RK73GB1J102J
RK73GB1J153J
RK73GB1J682J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
270
18
1.0K
15K
6.8K
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R19
R20
R21
R22
R23
RK73GB1J181J
RK73GB1J100J
RK73GB1J331J
RK73GB1J224J
RK73GB1J823J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
180
10
330
220K
82K
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R86
R87
R88
R89
R90
RK73GB1J271J
RK73GB1J472J
RK73GB1J470J
RK73GB1J102J
R92-1252-05
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
270
4.7K
47
1.0K
0 OHM
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R24
R25
R26
R27,28
R29
RK73GB1J822J
RK73GB1J153J
RK73GB1J470J
RK73GB1J331J
RK73GB1J392J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
8.2K
15K
47
330
3.9K
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R91
R92
R93
R94
R95
RK73GB1J271J
RK73GB1J180J
RK73GB1J271J
RK73GB1J103J
RK73GB1J102J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
270
18
270
10K
1.0K
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R30,31
R32
R33
R34
R35
RK73GB1J470J
RK73GB1J103J
RK73GB1J180J
RK73GB1J470J
RK73GB1J180J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
47
10K
18
47
18
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R96
R97-102
R103,104
R105
R106
R92-1252-05
RK73GB1J102J
R92-1061-05
RK73GB1J103J
RK73GB1J102J
CHIP R
0 OHM
CHIP R
1.0K
JUMPER REST
CHIP R
10K
CHIP R
1.0K
J
1/16W
J
1/16W
0 OHM
J
1/16W
J
1/16W
R36
R37
R38
R39
R40
RK73GB1J560J
RK73GB1J180J
RK73GB1J103J
RK73GB1J331J
RK73GB1J153J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
56
18
10K
330
15K
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R107
R108
R109
R110
R131
RK73GB1J103J
RK73GB1J560J
RK73GB1J104J
RK73GB1J560J
RK73GB1J221J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
10K
56
100K
56
220
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R41
R42
R43
R44
R45
RK73GB1J682J
RK73GB1J104J
RK73GB1J331J
RK73GB1J100J
R92-1252-05
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
6.8K
100K
330
10
0 OHM
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R132
R133
R134
R135
R136
RK73GB1J472J
RK73GB1J2R2J
RK73GB1J223J
RK73GB1J101J
RK73GB1J123J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
4.7K
2.2
22K
100
12K
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
44
KH : TS-480HX (K)
EH : TS-480HX (E)
KS : TS-480SAT (K)
ES : TS-480SAT (E)
TS-480HX/480SAT
PARTS LIST
TX-RX UNIT (X57-663X-XX)
Ref. No.
New
Address parts
Parts No.
Destination
Description
Ref. No.
New
Address parts
Parts No.
Destination
Description
R137
R138
R139
R140,141
R142
RK73GB1J563J
RK73GB1J103J
RK73GB1J101J
RK73GB1J471J
RK73GB1J472J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
56K
10K
100
470
4.7K
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R286
R287
R289
R290,291
R292,293
RK73FB2A102J
RK73GB1J101J
RK73GB1J472J
RK73GB1J103J
RK73GB1J222J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
1.0K
100
4.7K
10K
2.2K
J
J
J
J
J
1/10W
1/16W
1/16W
1/16W
1/16W
R143
R144
R145
R146,147
R148
RK73GB1J104J
RK73GB1J272J
RK73GB1J101J
RK73GB1J103J
RK73GB1J223J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
100K
2.7K
100
10K
22K
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R294
R295-297
R298
R300
R301,302
RK73GB1J223J
RK73GB1J103J
RK73GB1J334J
RK73GB1J334J
R92-1252-05
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
22K
10K
330K
330K
0 OHM
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R149
R151,152
R153
R154,155
R201,202
RK73GB1J474J
RK73GB1J153J
RK73FB2A4R7J
RK73GB1J331J
RK73GB1J473J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
470K
15K
4.7
330
47K
J
J
J
J
J
1/16W
1/16W
1/10W
1/16W
1/16W
R303
R305
R306
R307
R308
RK73GB1J223J
RK73GB1J102J
RK73GB1J682J
RK73GB1J102J
RK73GB1J101J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
22K
1.0K
6.8K
1.0K
100
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R203
R206
R209
R210
R211
RK73GB1J102J
RK73GB1J473J
RK73GB1J153J
RK73GB1J104J
RK73GB1J103J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
1.0K
47K
15K
100K
10K
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R309
R310
R311
R312
R313
RK73GB1J223J
RK73GB1J472J
RK73GB1J332J
RK73GB1J474J
RK73GB1J473J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
22K
4.7K
3.3K
470K
47K
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R212
R215
R217,218
R220
R221
RK73GB1J473J
RK73GB1J101J
RK73GB1J102J
RK73GB1J473J
RK73GB1J102J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
47K
100
1.0K
47K
1.0K
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R314-316
R317
R318-320
R321
R322
RK73GB1J103J
RK73GB1J563J
RK73GB1J101J
R92-1061-05
RK73GB1J472J
CHIP R
10K
CHIP R
56K
CHIP R
100
JUMPER REST
CHIP R
4.7K
J
1/16W
J
1/16W
J
1/16W
0 OHM
J
1/16W
R223
R224,225
R227
R228
R231
RK73GB1J102J
RK73GB1J473J
RK73GB1J101J
RK73GB1J473J
RK73GB1J473J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
1.0K
47K
100
47K
47K
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R323
R324
R325-327
R328-331
R332,333
RK73GB1J473J
RK73GB1J474J
RK73GB1J473J
RK73GB1J103J
RK73GB1J101J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
47K
470K
47K
10K
100
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R234,235
R236
R237
R239
R240
RK73GB1J473J
RK73GB1J153J
RK73GB1J103J
RK73GB1J102J
RK73GB1J473J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
47K
15K
10K
1.0K
47K
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R334,335
R336
R337
R338
R339-344
RK73GB1J472J
RK73GB1J101J
RK73GB1J104J
R92-1252-05
RK73GB1J101J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
4.7K
100
100K
0 OHM
100
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R242
R246
R247
R248
R251
RK73GB1J183J
R92-0699-05
RK73GB1J822J
RK73GB1J562J
RK73GB1J223J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
18K
10
8.2K
5.6K
22K
J
J
J
J
J
1/16W
1/2W
1/16W
1/16W
1/16W
R351
R352
R353
R354
R355-362
RK73GJ1J103D
RK73GJ1J393D
RK73GJ1J103D
RK73GJ1J393D
RK73GB1J101J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
10K
39K
10K
39K
100
D
D
D
D
J
1/16W
1/16W
1/16W
1/16W
1/16W
R252
R253
R254
R255
R256
RK73GB1J103J
RK73GB1J102J
RK73GB1J103J
RK73GB1J223J
RK73GB1J473J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
10K
1.0K
10K
22K
47K
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R364-366
R371,372
R373
R374
R375,376
RK73GB1J470J
RK73GB1J473J
RK73GJ1J392D
RK73GB1J102J
RK73GB1J101J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
47
47K
3.9K
1.0K
100
J
J
D
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R258
R259
R260
R261
R262
RK73GB1J822J
RK73GB1J562J
R92-1252-05
RK73GB1J183J
RK73GB1J223J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
8.2K
5.6K
0 OHM
18K
22K
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R451,452
R453,454
R455,456
R457-459
R460
RK73GB1J101J
RK73GB1J221J
RK73GB1J391J
RK73GB1J102J
RK73GB1J101J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
100
220
390
1.0K
100
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R264-267
R269-272
R273
R274
R275-277
RK73GB1J223J
RK73GB1J103J
RK73GB1J223J
RK73GB1J101J
RK73GB1J223J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
22K
10K
22K
100
22K
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R461
R462
R463
R464
R465
RK73GB1J470J
RK73GB1J153J
RK73GB1J682J
RK73GB1J221J
RK73GB1J101J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
47
15K
6.8K
220
100
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R278,279
R280
R281,282
R283,284
R285
RK73GB1J101J
RK73GB1J223J
RK73GB1J101J
RK73GB1J104J
RK73GB1J101J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
100
22K
100
100K
100
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R466
R468
R469-471
R501
R502
RK73GB1J391J
RK73GB1J102J
R92-0670-05
RK73GB1J101J
RK73GB1J104J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
390
1.0K
0 OHM
100
100K
J
J
1/16W
1/16W
J
J
1/16W
1/16W
KH : TS-480HX (K)
EH : TS-480HX (E)
KS : TS-480SAT (K)
ES : TS-480SAT (E)
EH,ES
EH,ES
KS,ES
KH,EH
KH,EH
KH,EH
45
TS-480HX/480SAT
PARTS LIST
TX-RX UNIT (X57-663X-XX)
Ref. No.
New
Address parts
Parts No.
Destination
Description
Ref. No.
New
Address parts
Parts No.
Destination
Description
R503,504
R505
R506
R507
R508
RK73GB1J101J
RK73GB1J102J
RK73GB1J221J
RK73GB1J102J
RK73GB1J223J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
100
1.0K
220
1.0K
22K
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R593
R594
R595,596
R597
R598
R92-1252-05
RK73GB1J470J
RK73GB1J474J
RK73GB1J222J
RK73GB1J331J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
0 OHM
47
470K
2.2K
330
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R509
R510
R511
R512
R513
RK73GB1J103J
RK73GB1J101J
RK73GB1J473J
RK73GB1J683J
RK73GB1J103J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
10K
100
47K
68K
10K
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R599
R600,601
R602
R603
R604
RK73GB1J101J
RK73GB1J471J
RK73GB1J102J
RK73GB1J681J
RK73GB1J221J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
100
470
1.0K
680
220
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R514
R515
R516
R517
R518
RK73GB1J223J
RK73GB1J102J
RK73GB1J103J
RK73GB1J152J
RK73GB1J223J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
22K
1.0K
10K
1.5K
22K
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R605
R606
R607
R608
R609
RK73GB1J102J
RK73GB1J331J
RK73GB1J821J
RK73GB1J103J
RK73GB1J473J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
1.0K
330
820
10K
47K
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R519
R520
R521
R522
R523
RK73GB1J333J
RK73GB1J221J
RK73GB1J102J
RK73GB1J563J
RK73GB1J101J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
33K
220
1.0K
56K
100
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R610
R611
R612
R622
R624
RK73GB1J104J
RK73GB1J472J
RK73GB1J104J
RK73GB1J101J
RK73GB1J471J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
100K
4.7K
100K
100
470
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R524
R525
R526
R527
R528
RK73GB1J681J
RK73GB1J103J
RK73GB1J154J
RK73GB1J101J
RK73GB1J471J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
680
10K
150K
100
470
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R625
R626
R627
R628
R629
RK73GB1J102J
RK73GB1J152J
RK73GB1J224J
RK73GB1J222J
RK73GB1J334J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
1.0K
1.5K
220K
2.2K
330K
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R551
R552
R554
R556
R557
RK73GB1J223J
R92-1252-05
RK73GB1J334J
R92-1252-05
RK73GB1J473J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
22K
0 OHM
330K
0 OHM
47K
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R631
R632
R633
R634,635
R636
RK73GB1J561J
RK73GB1J102J
RK73GB1J331J
RK73GB1J102J
RK73GB1J273J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
560
1.0K
330
1.0K
27K
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R558
R559
R560
R562,563
R564
RK73GB1J102J
RK73GB1J222J
RK73GB1J102J
RK73GB1J332J
RK73GB1J104J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
1.0K
2.2K
1.0K
3.3K
100K
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R637
R638
R640
R641
R642
RK73GB1J102J
RK73GB1J273J
R92-1252-05
RK73GB1J331J
RK73GB1J471J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
1.0K
27K
0 OHM
330
470
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R565
R566
R567
R568
R569
RK73GB1J393J
RK73GB1J101J
RK73GB1J331J
RK73GB1J103J
RK73GB1J470J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
39K
100
330
10K
47
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R643
R644
R645
R646
R647
RK73GB1J332J
RK73GB1J562J
RK73GB1J681J
RK73GB1J102J
RK73GB1J473J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
3.3K
5.6K
680
1.0K
47K
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R570
R571
R572
R573
R574
RK73GB1J104J
RK73GB1J222J
RK73GB1J102J
RK73GB1J101J
RK73GB1J104J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
100K
2.2K
1.0K
100
100K
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R648
R649
R650,651
R652
R653
RK73GB1J102J
RK73GB1J473J
RK73GB1J102J
RK73GB1J103J
RK73GB1J102J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
1.0K
47K
1.0K
10K
1.0K
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R575
R576
R577
R578
R579
RK73GB1J393J
RK73GB1J472J
RK73GB1J331J
RK73GB1J104J
RK73GB1J103J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
39K
4.7K
330
100K
10K
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R654
R655
R656
R657
R658
RK73GB1J103J
RK73GB1J223J
RK73GB1J821J
RK73GB1J122J
RK73GB1J471J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
10K
22K
820
1.2K
470
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R580
R583
R584
R586
R587
RK73GB1J470J
RK73GB1J101J
RK73GB1J474J
RK73GB1J470J
RK73GB1J222J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
47
100
470K
47
2.2K
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R681
R682
R683
R685
R686
RK73GB1J123J
R92-1252-05
RK73GB1J474J
RK73GB1J102J
RK73GB1J274J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
12K
0 OHM
470K
1.0K
270K
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R588
R589
R590
R591
R592
RK73GB1J471J
RK73GB1J562J
RK73GB1J104J
RK73GB1J274J
RK73GB1J331J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
470
5.6K
100K
270K
330
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R687
R688
R689
R690
R691
R92-1252-05
RK73GB1J102J
RK73GB1J333J
RK73GB1J103J
RK73GB1J102J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
0 OHM
1.0K
33K
10K
1.0K
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
46
KH : TS-480HX (K)
EH : TS-480HX (E)
KS : TS-480SAT (K)
ES : TS-480SAT (E)
TS-480HX/480SAT
PARTS LIST
TX-RX UNIT (X57-663X-XX)
Ref. No.
New
Address parts
Parts No.
Destination
Description
Ref. No.
New
Address parts
Parts No.
Destination
Description
R692
R693-697
R698
R699
R700
RK73GB1J153J
RK73GB1J473J
RK73GB1J103J
RK73GB1J102J
RK73GB1J822J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
15K
47K
10K
1.0K
8.2K
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R804
R804
R805
R806
R807
RK73GB1J103J
RK73GB1J153J
RK73GB1J473J
RK73GB1J103J
RK73GB1J472J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
10K
15K
47K
10K
4.7K
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
KH,EH
KS,ES
R701
R702
R703
R704
R705
RK73GB1J330J
RK73GB1J103J
RK73GB1J331J
RK73GB1J104J
RK73GB1J473J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
33
10K
330
100K
47K
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R808-811
R810,811
R812
R813
R814
RK73GB1J333J
RK73GB1J333J
RK73GB1J104J
RK73GB1J334J
RK73GB1J333J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
33K
33K
100K
330K
33K
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
KH,EH
KS,ES
R706
R707
R708
R709,710
R711
RK73GB1J104J
RK73GB1J123J
RK73GB1J683J
RK73GB1J473J
RK73GB1J103J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
100K
12K
68K
47K
10K
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R815
R816
R816
R817
R818
RK73GB1J222J
RK73GB1J103J
RK73GB1J153J
RK73GB1J224J
RK73GB1J394J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
2.2K
10K
15K
220K
390K
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R712
R713
R714
R715
R731
RK73GB1J472J
R92-1252-05
RK73GB1J473J
RK73GB1J223J
RK73GB1J101J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
4.7K
0 OHM
47K
22K
100
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R819
R820
R820-822
R822
R823
RK73GB1J334J
RK73GB1J105J
RK73GB1J105J
RK73GB1J105J
R92-1252-05
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
330K
1.0M
1.0M
1.0M
0 OHM
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R732
R733
R734
R735
R736
RK73GB1J474J
RK73GB1J102J
R92-1252-05
RK73GB1J103J
RK73GB1J223J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
470K
1.0K
0 OHM
10K
22K
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R824
R826,827
R827
R828
R830
RK73GB1J471J
RK73GB1J471J
RK73GB1J471J
RK73GB1J330J
R92-1252-05
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
470
470
470
33
0 OHM
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R737
R738
R739
R740
R741
R92-1252-05
RK73GB1J473J
RK73GB1J103J
RK73GB1J104J
RK73GB1J393J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
0 OHM
47K
10K
100K
39K
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R832,833
R834
R835
R837
R838
R92-1252-05
RK73GB1J103J
RK73GB1J224J
RK73GB1J273J
RK73GB1J822J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
0 OHM
10K
220K
27K
8.2K
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R741
R742
R743
R744
R745,746
RK73GB1J683J
RK73GB1J104J
RK73GB1J273J
RK73GB1J222J
RK73GB1J101J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
68K
100K
27K
2.2K
100
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R839
R840
R841
R845
R846
RK73GB1J102J
RK73GB1J103J
RK73GB1J104J
RK73GB1J104J
RK73GB1J102J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
1.0K
10K
100K
100K
1.0K
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R747,748
R749
R750
R751
R752
RK73GB1J104J
RK73GB1J564J
RK73GB1J104J
RK73GB1J473J
RK73GB1J104J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
100K
560K
100K
47K
100K
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R847
R848
R850
R851
R852
RK73GB1J103J
RK73GB1J563J
RK73GB1J560J
R92-1252-05
RK73GB1J104J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
10K
56K
56
0 OHM
100K
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R754
R756
R757
R759
R760
RK73GB1J151J
RK73GB1J103J
RK73GB1J472J
RK73GB1J221J
RK73GB1J104J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
150
10K
4.7K
220
100K
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R853
R854
R856
R857
R858
RK73GB1J332J
R92-1252-05
R92-1252-05
RK73GB1J222J
RK73GB1J561J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
3.3K
0 OHM
0 OHM
2.2K
560
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R762
R763
R764
R765
R766,767
RK73FB2A4R7J
RK73GB1J101J
RK73GB1J473J
RK73GB1J223J
RK73GB1J102J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
4.7
100
47K
22K
1.0K
J
J
J
J
J
1/10W
1/16W
1/16W
1/16W
1/16W
R859
R901
R902,903
R904
R905
RK73GB1J101J
RK73GB1J103J
RK73GB1J102J
RK73GB1J223J
RK73GB1J471J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
100
10K
1.0K
22K
470
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R768
R769
R770
R772
R772
RK73FB2A4R7J
RK73GB1J102J
RK73GB1J473J
RK73GB1J224J
RK73GB1J394J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
4.7
1.0K
47K
220K
390K
J
J
J
J
J
1/10W
1/16W
1/16W
1/16W
1/16W
R906
R907
R908
R909
R911
RK73GB1J104J
RK73GB1J393J
RK73GB1J101J
RK73GB1J330J
RK73GB1J471J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
100K
39K
100
33
470
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R774
R775
R801
R802
R803
RK73GB1J182J
RK73GB1J183J
R92-1252-05
RK73GB1J101J
RK73GB1J333J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
1.8K
18K
0 OHM
100
33K
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
R912
R913
R914
R918
R919
RK73GB1J470J
RK73GB1J102J
RK73GB1J331J
R92-1252-05
RK73GB1J102J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
47
1.0K
330
0 OHM
1.0K
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
KH : TS-480HX (K)
EH : TS-480HX (E)
KS : TS-480SAT (K)
ES : TS-480SAT (E)
KH,EH
KS,ES
KH,EH
KS,ES
KH,EH
KS,ES
KS,ES
KH,EH
KS,ES
KH,EH
KS,ES
47
TS-480HX/480SAT
PARTS LIST
TX-RX UNIT (X57-663X-XX)
Ref. No.
New
Address parts
Parts No.
Destination
Description
Ref. No.
New
Address parts
Parts No.
Destination
Description
R920
R921
R922
R923
R924
RK73GB1J222J
RK73GB1J102J
RK73GB1J222J
RK73GB1J103J
RK73GB1J102J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
2.2K
1.0K
2.2K
10K
1.0K
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
D353,354
D355,356
D357
D358
D359
DA221
1SS388
MINISMDC050-02
RLS245
1SS388
DIODE
DIODE
VARISTOR
DIODE
DIODE
R925
R926
R927
R931,932
R933,934
RK73GB1J822J
RK73GB1J101J
RK73GB1J562J
RK73GB1J152J
RK73GB1J392J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
8.2K
100
5.6K
1.5K
3.9K
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
D360
D451,452
D453,454
D455
D456
MINISMDC050-02
KV1470
HSC277
KV1470
HSC277
VARISTOR
VARIABLE CAPACITANCE DIODE
DIODE
VARIABLE CAPACITANCE DIODE
DIODE
R935
R936
R937-939
R940
R941,942
RK73GB1J101J
RK73GB1J331J
RK73GB1J101J
RK73GB1J391J
R92-1252-05
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
100
330
100
390
0 OHM
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
D501
D551
D552
D555
D557,558
RB706F-40
RN731V
HSM88AS
HSM88AS
KDS121E
DIODE
DIODE
DIODE
DIODE
DIODE
R943,944
R945
R946
R947
R948,949
RK73GB1J102J
RK73GB1J392J
RK73GB1J101J
RK73GB1J391J
R92-1252-05
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
1.0K
3.9K
100
390
0 OHM
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
D559
D622,623
D624,625
D681-683
D733,734
1SS388
MA2S111
1SS388
MA2S111
1SS388
DIODE
DIODE
DIODE
DIODE
DIODE
R950
R951-954
R955-958
R971
R972
RK73GB1J681J
RK73GB1J152J
RK73GB1J101J
R92-1252-05
RK73GB1J471J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
680
1.5K
100
0 OHM
470
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
D735
D736
D801
D802
D804
KDS121E
MA2S111
015AZ5.1-Y
MA2S111
015AZ6.8
DIODE
DIODE
ZENER DIODE
DIODE
ZENER DIODE
R973
R975,976
R977
R978
R979
RK73GB1J823J
RK73GB1J101J
RK73GB1J102J
R92-1252-05
RK73GB1J101J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
82K
100
1.0K
0 OHM
100
J
J
J
J
J
1/16W
1/16W
1/16W
1/16W
1/16W
D805
D805,806
D806
D807,808
D809
1SS388
MA2S111
MA2S111
KDS120E
015AZ3.3-X
DIODE
DIODE
DIODE
DIODE
ZENER DIODE
R980
R981
R982
VR1,2
VR2
RK73GB1J103J
RK73GB1J471J
RK73GB1J332J
R12-7484-05
R12-7484-05
CHIP R
10K
J
1/16W
CHIP R
470
J
1/16W
CHIP R
3.3K
J
1/16W
TRIMMING POT. (4.7K/8)
TRIMMING POT. (4.7K/8)
D810
D811
D812,813
D816-819
D901-904
015AZ5.1-Y
MA2S111
1SS388
MA2S111
RN731V
ZENER DIODE
DIODE
DIODE
DIODE
DIODE
VR621,622
R12-7484-05
TRIMMING POT. (4.7K/8)
K131
K731
S201
S51-1420-05
S51-1428-05
S62-0412-05
RELAY
RELAY
SLIDE SWITCH
D905
D906
D931
D932-936
D937
1SS388
RN731V
RN731V
1SV312
HSC277
DIODE
DIODE
DIODE
DIODE
DIODE
D1
D2,3
D4
D131-135
D136
KV1470
HSC277
MA2S111
DA221
MA2S111
VARIABLE CAPACITANCE DIODE
DIODE
DIODE
DIODE
DIODE
D938
D939-941
D944,945
IC1,2
IC3
HVC131
HSC277
1SS388
AD9835BRU
LMX2306TMX
DIODE
DIODE
DIODE
MOS IC
MOS IC
✽
015AZ3.3-X
MA2S111
015AZ5.1-Y
MINISMDC050-02
015AZ6.8
ZENER DIODE
DIODE
ZENER DIODE
VARISTOR
ZENER DIODE
IC201
IC202
IC203
IC204
IC205
TC74HC4052AFT
AT25640N10SI27
ADM202EARU
HD64F2338VFC25
HD74HCT541T
MOS IC
ROM IC
MOS IC
MCU
MOS IC
✽
✽
✽
MA2S111
015AZ10-Y
015AZ3.3-X
KDS121E
MA2S111
DIODE
ZENER DIODE
ZENER DIODE
DIODE
DIODE
IC207
IC208
IC209
IC210,211
IC212
✽
HD74LV2G34AUS
TC7WT125FU
HD74LV2G34AUS
PST9130NR
M62364FP
MOS IC
MOS IC
MOS IC
MOS IC
MOS IC
015AZ3.3-X
KDZ18EV
RLS245
KDZ18EV
KDZ18EV
ZENER DIODE
ZENER DIODE
DIODE
ZENER DIODE
ZENER DIODE
IC213
IC214
IC215
IC216
IC217
✽
XC6203P332P
NJM2100V
XC6203P332P
XC62FP1802P
AK4550VT
MOS IC
MOS IC
MOS IC
MOS IC
MOS IC
D137
D138
D139
D202
D203,204
D205
D206
D207
D208
D210
D211
D212
D213
D351,352
D352
48
✽
✽
✽
✽
✽
KH,EH
KS,ES
KH,EH
KS,ES
✽
✽
✽
✽
✽
✽
✽
✽
✽
✽
✽
KH : TS-480HX (K)
EH : TS-480HX (E)
KS,ES
KH,EH
KS,ES
KS : TS-480SAT (K)
ES : TS-480SAT (E)
TS-480HX/480SAT
PARTS LIST
TX-RX UNIT (X57-663X-XX)
SUB UNIT (X58-4900-XX)
Ref. No.
New
Address parts
Parts No.
Description
Destination
Ref. No.
✽
NJM2100V
BU4066BCFV
320VC5402PGE
NJM2100V
HD74LV541AT
MOS IC
MOS IC
MPU
MOS IC
MOS IC
Q552
Q553
Q554
Q556-558
Q559
✽
✽
TC7S04FU
NJM2100V
TC7WT125FU
HD74LV1GT125A
HD74LV2G34AUS
MOS IC
MOS IC
MOS IC
MOS IC
MOS IC
Q560
Q561
Q562
Q563
Q621-623
✽
TA31136FN
TC7W66FK
TA4101F
TC75S51FE
NJM1496V
MOS IC
MOS IC
IC (IC)
MOS IC
BI-POLAR IC
Q624
Q625
Q681
Q682
Q683
M62353AGP
BU4066BCFV
NJM2100V
BU4S66
TC7S66FU
MOS IC
MOS IC
MOS IC
MOS IC
MOS IC
Q684
Q685,686
Q731
Q732,733
Q734
IC695
IC731
IC732
IC733
IC734
XC6204B502MR
BU2099FV
NJM2904V
BU4066BCFV
LA4446
MOS IC
MOS IC
MOS IC
MOS IC
BI-POLAR IC
Q735
Q737
Q803
Q805
Q806
IC801
IC802
Q1-8
Q9
Q10-12
NJM2904V
NJM2902V
2SC4617(R)
UMX2N
2SC4617(R)
MOS IC
MOS IC
TRANSISTOR
TRANSISTOR
TRANSISTOR
Q807
Q901
Q902,903
Q971
TH551
Q13
Q14,15
Q16
Q17
Q18
RN47A5
2SC4649(N,P)
KRC418E
2SC4617(R)
UMX2N
TRANSISTOR
TRANSISTOR
DIGITAL TRANSISTOR
TRANSISTOR
TRANSISTOR
Q19
Q131
Q132
Q133
Q134,135
2SC4617(R)
KRC402E
2SB1188(Q,R)
UMX2N
RN1704
TRANSISTOR
DIGITAL TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
Q136
Q137,138
Q201
Q202
Q203
2SK1824
KRC402E
2SC4617(R)
2SB1188(Q,R)
RN47A5
FET
DIGITAL TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
KRC401E
KRC402E
HN7G01FU
2SK508NV(K52)
KRC418E
DIGITAL TRANSISTOR
DIGITAL TRANSISTOR
TRANSISTOR
FET
DIGITAL TRANSISTOR
2SC4649(N,P)
2SK508NV(K52)
KRC418E
2SC3356
UMX2N
TRANSISTOR
FET
DIGITAL TRANSISTOR
TRANSISTOR
TRANSISTOR
R3,4
R5,6
R7,8
R9,10
R9,10
2SK1824
2SC4617(Q)
KRA302E
2SC4617(R)
3SK317
FET
TRANSISTOR
DIGITAL TRANSISTOR
TRANSISTOR
FET
D1,2
Q1,2
IC218
IC219
IC220
IC221
IC222
IC223
IC224
IC225
IC226
IC227
IC551
IC552
IC553
IC554
IC621
IC681
IC682
IC683
IC684
IC685
Q204
Q205
Q207
Q451,452
Q453,454
Q455
Q456
Q457
Q501
Q502
Q503
Q504-506
Q507
Q508
Q551
KH : TS-480HX (K)
EH : TS-480HX (E)
✽
✽
✽
✽
✽
✽
✽
KS : TS-480SAT (K)
ES : TS-480SAT (E)
New
Address parts
Parts No.
✽
2SC4617(R)
KRC402E
3SK317
2SC4617(R)
KRC402E
TRANSISTOR
DIGITAL TRANSISTOR
FET
TRANSISTOR
DIGITAL TRANSISTOR
✽
RN1704
KRC402E
KRC404E
KRC402E
2SC4617(R)
TRANSISTOR
DIGITAL TRANSISTOR
DIGITAL TRANSISTOR
DIGITAL TRANSISTOR
TRANSISTOR
2SA1774(R)
UMX2N
RN47A5
HN7G01FU
2SC4617(R)
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
HN7G01FU
KRC402E
RN1704
KRA555U
2SK1824
TRANSISTOR
DIGITAL TRANSISTOR
TRANSISTOR
DIGITAL TRANSISTOR
FET
2SD1624(S)
RN47A5
RN1701
KRC404E
2SC4617(R)
TRANSISTOR
TRANSISTOR
TRANSISTOR
DIGITAL TRANSISTOR
TRANSISTOR
KRA318E
3SK317
KRC402E
2SC3356
157-502-65001
DIGITAL TRANSISTOR
FET
DIGITAL TRANSISTOR
TRANSISTOR
THERMISTOR
TH552
TH621,622
TH901
TH902
TH971
157-503-65001
157-471-65001
157-101-65001
157-302-65801
157-101-65001
THERMISTOR
THERMISTOR
THERMISTOR
THERMISTOR
THERMISTOR
TH972
157-302-65801
THERMISTOR
✽
✽
✽
✽
✽
✽
SUB UNIT (X58-4900-XX)
Destination
Description
-00 : KH,EH -01 : KS,ES
C1
C2,3
C4-7
C4,5
C6,7
CK73FB1H102K
CK73FB1E104K
CC73FCH1H220J
CC73FCH1H220J
CC73FCH1H331J
CHIP C
CHIP C
CHIP C
CHIP C
CHIP C
1000PF
0.10UF
22PF
22PF
330PF
K
K
J
J
J
C8,9
C10
CC73FCH1H331J
CK73FB1E104K
CHIP C
CHIP C
330PF
0.10UF
J
K
F01-1029-04
RADIATION PLATE
RK73FB2A332J
R92-3569-05
RK73FB2A1R0J
RK73FB2A270J
RK73FB2A560J
CHIP R
CHIP R
CHIP R
CHIP R
CHIP R
1SS388
2SK3075-H
DIODE
FET
-
✽
✽
3.3K
330
1.0
27
56
J
J
J
J
J
1/10W
1/4W
1/10W
1/10W
1/10W
KS,ES
KH,EH
KH,EH
KS,ES
KS,ES
KH,EH
49
TS-480HX/480SAT
EXPLODED VIEW (MAIN BODY UPPER SIDE)
A
B
8
D
D
D
15
Dx2
D M2.6 x 6 (OC) BLK : N33-2606-45
L M2.6 x 8 (Br-Tap) : N87-2608-46
1
D
D
70
63
1
62
70
D
Lx12
63
Lx2
54
55
Lx2
77x2
2
59
Final unit
(B/3)
Lx11
41 L
39
L
L
40
Final unit
(C/3)
43
27
TX-RX unit
(B/2)
L
39
L
TX-RX unit
(A/2)
27
L
L
65
66
3
3
5
50
67
50
Parts with the exploded numbers larger than 700 are not supplied.
TS-480HX/480SAT
EXPLODED VIEW (MAIN BODY LOWER SIDE) : TS-480SAT
C
D
10
14
25
95
12
D
9
95
D
95
D
64
1
95
2
9
B
D
E
F
G
H
L
ø4 (FW)
M2.6 x 6 (OC) BLK
M3 x 14 (Bi) BLK
M4 x 10 (Bi)
M3 x 20 BLK
M2.6 x 8
M2.6 x8 (Br-Tap)
: N15-1040-46
: N33-2606-45
: N35-3014-45
: N35-4010-46
: N66-3020-45
: N67-2608-46
: N87-2608-46
Lx8
53
Lx7
126
39
Hx2
(Sub unit)
2
Lx9
Hx6
48
Final unit (A/3)
39
RF unit
L
E type
56
3
51
3
Ex2
Gx2
Ex2
Gx2
49
52
F
BB
Parts with the exploded numbers larger than 700 are not supplied.
51
TS-480HX/480SAT
EXPLODED VIEW (MAIN BODY LOWER SIDE) : TS-480HX
E
F
10
25
14
95
12
D
9
95
D
95
64
D
1
95
2
9
B
D
F
G
H
L
ø4 (FW)
M2.6 x 6 (OC) BLK
M4 x 10 (Bi)
M3 x 20 BLK
M2.6 x 8
M2.6 x8 (Br-Tap)
: N15-1040-46
: N33-2606-45
: N35-4010-46
: N66-3020-45
: N67-2608-46
: N87-2608-46
78
Lx8
53
2
Lx10
L
(Sub unit)
Hx2
48
Hx13
E type
39
Final unit
(A/3)
39
Lx7
126
RF unit
L
E type
52
3
49
3
Gx2
Gx2
Gx2
52
52
Gx2
49
F
B
B
Parts with the exploded numbers larger than 700 are not supplied.
TS-480HX/480SAT
EXPLODED VIEW (PANEL)
G
H
42
J
81
121
J
68
J
1
6
K
72
97
Top
82
K
Bottom
201
202
205
205
Front
203 x2
204
2
207
Display unit
(B/3)
79
206
Rear
Right Side
Green
75
76
79
124
79
Front
Rear
Right Side
Blue
74
76
4
110
58
3
Display unit
(C/3)
Display unit
(A/3)
A
75
106
109
69
60
C
105
A
C
J M2 x 16
K M2.6 x 5
A
107
61
108
: N14-0582-14
: N19-0670-05
: N80-2016-45
: N82-2605-46
110
58
111
Parts with the exploded numbers larger than 700 are not supplied.
53
TS-480HX/480SAT
PACKING
J
K
44 DIN plug (6P)
(E57-0404-05)
71 Sheet (G11-4228-04)
91 Protection bag (H25-2343-04)
101 Bracket (J29-0707-03)
73 Sheet (G11-4269-04) x 4
90 Protection bag (H25-2327-04)
96 Stand (J09-0409-03)
80 Cushion (G13-2022-14)
91 Protection bag (H25-2343-04)
98 Bracket (J29-0663-13)
91
q
89 Protection bag
(H25-2320-04)
30
1 90
104
118
Protection bag
(H25-2343-04)
100 Bracket
(J29-0706-04) x 2
e
w
Modular cable (Panel, 20cm) (E30-3500-05) : EH,ES
Protection bag (H25-2327-04) : EH,ES
Handle (K01-0420-05) : EH,ES
Screw set (N99-2041-05) : EH,ES
t
r
y
!1
u
87
Protection bag
(H25-0796-04)
122 Microphone
(T91-0638-05)
o
i
!0
85 Packing fixture
(H12-3154-02)
28 Modular cable (Panel, 4m)
(E30-3488-05)
92 Protection bag
(H25-2352-04)
83 Packing fixture
(H12-3142-02)
2
92 Protection bag
(H25-2352-04)
q 80 Cushion (G13-2022-14) : EH,ES
91 Protection bag (H25-2343-04) : EH,ES
98 Bracket (J29-0663-13) : EH,ES
84 Packing fixture
(H12-3153-02)
w 45 DIN plug (8P) (E57-0405-05)
e 117 Screw set (N99-2035-05)
r 47
47
48
86
Fuse (Blade) (25A/32V) (F05-2531-05) : KS,ES
Fuse (Blade) (25A/32V) (F05-2531-05) x 2 : KH,EH
Fuse (Blade) (4A/32V) (F06-4027-05)
Protection bag (H25-0029-04)
93 Item carton case
(H52-1944-02) : KH
(H52-1945-02) : KS
(H52-1946-02) : EH
(H52-1947-02) : ES
t 88 Protection bag (H25-2013-04) :ES
114 Line filter (with band) (L79-1408-05) : ES
3
y 88 Protection bag (H25-2013-04) : EH
114 Line filter (with band) (L79-1408-05) x 2 : EH
u 115 Line filter (L79-1417-05)
i 92 Protection bag (H25-2352-04) : EH,ES
99 Bracket (J29-0705-01) : EH,ES
o 11
29
47
87
54
Rating label (B42-7003-04) x 2 : EH,ES
DC cord (E30-3489-05)
Fuse (Blade) (25A/32V) (F05-2531-05)
Protection bag (H25-0796-04)
!0 11 Rating label
(B42-7003-04) x 2 : EH
29 DC cord
(E30-3489-05) : KH,EH
47 Fuse (Blade) (25A/32V)
(F05-2531-05) : KH,EH
87 Protection bag
(H25-0796-04) : KH,EH
!1 17
18
19
20
21
22
23
24
92
700
Schematic diagram (B52-0619-00) : KH,KS
Schematic diagram (B52-0620-10) : KH,KS
Instruction manual (B62-1735-10)
Instruction manual (B62-1736-10) : EH,ES
Instruction manual (B62-1750-10) : EH,ES
Instruction manual (B62-1751-10) : EH,ES
Instruction manual (B62-1752-10) : EH,ES
Instruction manual (B62-1753-10) : EH,ES
Protection bag (H25-2352-04)
Warranty card
Parts with the exploded numbers larger than 700 are not supplied.
TS-480HX/480SAT
ADJUSTMENT
Required Test Equipment
1. DC Voltmeter (DC V.M)
1) Input resistance : More than 1MΩ
2) Voltage range : 1.5 to 1000V AC/DC
Note : A high-recision multimeter may be used. However, accurate readings can not be obtained for highimpedance circuits.
2. DC Ammeter
1) Current range : 100mA, 1.5A, 15A, high-precision ammeter may be used.
3. RF VTVM (RF V.M)
1) Input impedance : 1MΩ and less than 3pF, min.
2) Voltage range : 10mV to 300V
3) Frequency range : 10kHz to 500MHz
4. AF Voltmeter (AF V.M)
1) Frequency range : 50Hz to 10kHz
2) Input resistance : 1MΩ or greater
3) Voltage range : 10mV to 30V
5. AF Generator (AG)
1) Frequency range : 200Hz to 5kHz
2) Output : 1mV or less to 1V, low distortion
6. AF Dummy Load (DM. SP)
1) Impedance : 8Ω
2) Dissipation : 3W or greater
7. Oscilloscope
Requires high sensitivity, and external synchronization
capability (150MHz or greater).
8. Standard Signal Generator (SSG)
1)
2)
3)
4)
Frequency range : 50kHz to 60MHz
Output : –133dBm/0.1µV to 7dBm/1V
Output impedance : 50Ω
AM and FM modulation can be possible
Note : Generator must be frequency stable.
10. Noise Generator (Noise G.)
Must generate ignition noise containing harmonics
beyond 30MHz.
11. Audio Analyzer
12. RF Dummy Load
1) Impedance : 150Ω and 50Ω
2) Dissipation : 150W or greater
250W or greater (TS-480HX)
13. Linear Detector
1) Frequency range : 60MHz or greater
14. Power Meter
1) Impedance : 50Ω
2) Dissipation : 300W continuous or greater
3) Frequency limits : 60MHz or greater
15. Spectrum Analyzer
1) Frequency range : 100kHz to 140MHz or greater
2) Bandwidth : 1kHz to 3MHz
16. Tracking Generator
17. Directional Coupler
18. Monitor Receiver
19. Microphone
MC-43S or MC-60S8 (with MJ-88)
20. Distortion Meter
21. Double Signal Pad (50Ω)
9. Frequency Counter (f. counter)
1) Minimum input voltage : 50mV
2) Frequency range : 150MHz or greater
55
TS-480HX/480SAT
ADJUSTMENT
Preparation
Unless otherwise specified, knobs and switches should
be set as follows.
POWER .................................................................. ON
IF SHIFT ............................................................ Center
AF ......................................................................... MIN
SQL ...................................................................... MIN
■ Remote control panel
• Front panel
XIT
PF
ANT
RIT
1/2
ATT/PR
E
AT
■ TX/RX unit
• Front panel
AF
MIC
1 REC
2 REC
CH1
CH2
4 TX MONI 5 RF.G
7
DATA
3 REC
KEY
9
VOX
CLR
0 OFF
MTR
AGC
M.IN
CH3
DNL
NAR
4 DELAY
MIC
8
NB/T
PANEL
PADDLE
SQL
PWR
EXT.SP
PROC
ENT
NR
FIL
BC
MODE
M VFO
QMR
MENU
M/V
A/B
CW.T
STEP
SG.SEL
FINE
SCAN
SPLIT
MHz
• Rear panel
KEY
• Rear panel (TS-480SAT)
2
1
Service Jig
A. Coaxial cable (E37-0620-05), about 37cm
• Rear panel (TS-480HX)
2
1
B. Flat cable (12P) (E37-1129-08), about 15cm
C. Data terminal short plug (W05-0611-00)
56
QMI
F.LOCK
REMOTE
COM
CL
HF/50MHz ALL MODE TRANSCEIVER TS-480
A=B
TF-SET
MULTI
IF
SHIFT
TS-480HX/480SAT
ADJUSTMENT
■ How to use the coaxial cable and the flat cable
1. Remove the three coaxial cables ( q, w, e ) from their
respective connectors on the TX-RX unit (A/2) and the RF
unit.
2. Remove the flat cable ( r ) from its connectors on the TXRX unit (A/2) and the final unit (C/3).
3. Remove the screws from the TX-RX unit (A/2 and B/2) and
the final unit (B/3) , then lift the two shield covers from the
unit.
4. Remove the flat spring that is attached to the chassis and
IC734.
5. Free the TX-RX unit (A/2 and B/2) from the chassis and lift
it sideways so as not to damage the two flat cables along
the side.
6. Replace the original three coaxial cables with the longer
cables ( t ), then insert them into their respective connectors on the TX-RX unit (A/2) and the RF unit.
7. Exchange the original flat cable with
the longer cable ( y ), then insert if
into its connectors on the TX-RX unit
5
(A/2) and the final unit (C/3).
Shielding
cover
Shielding cover
TX-RX
unit (B/2)
Flat spring
FINAL
unit (B/3)
IC734
4
2
FINAL
unit (C/3)
3
1
6
RF unit
1
3
Flat cble
2
TX-RX
unit (A/2)
■ How to use the data terminal short plug
Insert the adjustment jig (W05-0611-00) into the DATA
connector located on the front panel of the transceiver.
• DATA connector pin assignment
y SQC t ANO
EXT.SP
MIC
PANEL
DATA
REMOTE
COM
e DTS
r NC
PADDLE
KEY
w GND q ANI
Terminals e and y are short circuited.
e DTS (SEND switch for DATA terminal)
Connect PTT output. If DTS is set to “GND”, data are sent
and the microphone will be mute.
y SQC (Squelch control output)
This outputs squelch control output.
57
TS-480HX/480SAT
ADJUSTMENT
Updating the Firmware
■ System requirements
• PC (Windows 95/ 98/ 98SE/ Me/ NT 4.0/ 2000/ XP)
• RS-232C straight cable
• Update software ”TS480UPDATE_S.EXE”
ware appears on the 7 segment display while the [MCHKSUM] appears on the 13 segment display.)
18. Turn the transceiver OFF.
S201
OFF (Normal)
ON (Update)
■ Note
1. Execute the full reset to ensure consistency with the
backup data after updating the Firmware.
2. When you do not want to remove data such as memory
channel data, save the data using the ARCP-480 before
updating the Firmware and write the data after updating
the Firmware.
■ Operating procedure
1. Disconnect the power cable from the transceiver.
2. Remove the upper case of the transceiver.
3. Set the slide switch (S201) of the TX-RX unit (X57-663 A/2)
to ON (move the switch toward the front ).
4. Connect the RS-232C terminal of the PC and the transceiver’s COM terminal via a RS-232C straight cable.
5. Connect the power cable with the transceiver.
Run the ”TS480UPDATE_S.EXE”. The following display
appears.
“File reference” button
7. Change the “COM Port” setting if necessary.
8. Change the “Baud Rate” setting if necessary. (Normally,
select “Auto”, but change it to a slower baud rate if communication errors frequently occur.)
9. Click the “File reference” button and select the firmware
to be written (.bin file).
10. Click the [Update] button to start writing. (When an error
occurs during updating, disconnect and connect the
power cable to reset the MCU. Then, click the [Update]
button again.)
11. Disconnect the RS-232C straight cable and the power
cable from the transceiver after completing writing.
12. Set the slide switch (S201) of the TX-RX unit (X57-663 A/
2) to OFF (move the switch toward the rear ).
13. Replace the upper case, which was removed in step.2,
onto the transceiver.
14. Reconnect the power cable, which was disconnected in
step.11, to the transceiver.
15. Perform the full reset. (Turn the transceiver ON while
pressing the [A=B] key, then press the [A=B] key again
when the reset confirmation message appears.)
16. Turn the transceiver OFF.
17. Check the checksum. (Turn the transceiver ON while
pressing the [MIC] key and [NR] key, to enter checksum
confirmation mode. The checksum of the updated firm-
58
Adjustment Mode
■ Outline
1. You can adjust the transceiver in service adjustment
mode (adjustment using the panel keys) or with manual
adjustment (turning a coil and a trimmer, etc).The service
adjustment mode (hereinafter referred to as “adjustment
mode”) has 79 items (Menu No. 00 to 78) and all adjustment data is stored in the EEPROM (X57-663 A/2 : IC202).
2. Enter adjustment mode and change each setting data.
3. New data will be written the EEPROM by performing
Menu No. 76 writing.
■ Operation procedures in adjustment mode
1. How to start the adjustment mode
• Insert the adjustment jig (W05-0611-00) into the DATA
connector located on the front panel of the transceiver.
• Turn the transceiver ON while pressing the [MIC] key and
[NR] key, to enter adjustment mode and the Menu No.
appears on the Memory Channel No. display.
Remove the adjustment jig from the transceiver when the
Menu No. appears.
Menu No.
2. Select adjustment mode Menu No.
Turn the [MULTI] knob to change the Menu No.
3. Change adjustment mode setting data
Setting data can be changed with [ ] or [ ] key.
4. Write adjustment mode data
Press [ ] or [ ] key on the main unit or [UP] or [DWN]
key on the microphone on Menu No. 76.
5. Cancel adjustment mode
Press the [MTR] key to return to the normal VFO mode.
Note: When the power is turned OFF in the middle in the
adjustment mode, it is canceled.
TS-480HX/480SAT
ADJUSTMENT
Adjustment Mode Menu (Menu No. 00~78)
No.
Apply 100W
Apply 200W
Display
Item
Frequency
Mode
00
IF SHIFT VR
Adjustment Item
YES
YES
IF.CENTR
Center
14.2M
USB
01
AGC Ref.
YES
YES
AGC REF
Referense
14.2M
USB
02
HF IF Gain
YES
YES
HF. GAIN
AGC Start
14.2M
USB
03
HF SSB S-Meter
YES
YES
HF.SSB S1
SSB S1
14.2M
USB
YES
YES
HF.SSB S9
SSB S9
29.2M
FM
29.2M
FM
04
05
06
HF FM S-Meter
07
YES
YES
HF.SSB SF
SSB S Full
YES
YES
HF.FM. S1
FM S1
YES
YES
HF.FM.SFUL
FM Full
HF FM Squelch
YES
YES
HF.FM.SQ.TH
FM threshold
YES
YES
HF.FM.SQ.TI
FM tight
10
50M IF Gain
YES
YES
50. GAIN
AGC Start
50.2M
USB
11
50M SSB S-Meter
YES
YES
50.SSB S1
SSB S1
50.2M
USB
YES
YES
50.SSB S9
SSB S9
50.2M
FM
50.2M
FM
08
09
12
13
YES
YES
50.SSB SF
SSB S Full
50M FM S-Meter
YES
YES
50.FM S1
FM S1
YES
YES
50.FMSFUL
FM Full
50M FM Squelch
YES
YES
50.FM.SQ.TH
FM threshold
YES
YES
50.FM.SQ.TI
FM tight
18
ALC Ref.
YES
YES
ALC REF
14.1M
14.1M
USB
19
POC
14.1M
USB
14.1M
USB
14
15
16
17
YES
N/A
POC 100W
100W
20
YES
N/A
POC 50W
50W
21
YES
N/A
POC 25W
25W
22
YES
N/A
POC 10W
10W
23
24
200W POC
YES
YES
POC 5W
5W
N/A
YES
2.POC 200
200W
25
N/A
N/A
2.POC 150
N/A
26
N/A
YES
2.POC 100
100W
27
N/A
YES
2.POC 50
50W
28
N/A
YES
2.POC 25
25W
N/A
YES
2.POC 10
10W
YES
N/A
TGC 1.8M
100W
1.83M
29
14.1M
30
TGC 1.8M
31
TGC 3.5M
YES
N/A
TGC 3.5M
100W
3.51M
32
TGC 5M
YES
N/A
TGC 5M
100W
5.3M
33
TGC 7M
YES
N/A
TGC 7M
100W
7.01M
34
TGC 10M
YES
N/A
TGC 10M
100W
10.1M
35
TGC 14M
YES
N/A
TGC 14M
100W
14.1M
36
TGC 18M
YES
N/A
TGC 18M
100W
18.1M
37
TGC 21M
YES
N/A
TGC 21M
100W
21.1M
38
TGC 24.9M
YES
N/A
TGC 24M
100W
24.9M
39
TGC 28M
YES
N/A
TGC 28M
100W
29.1M
40
TGC 50M
YES
N/A
TGC 50M
100W
51.9M
41
TGC 1.8M
N/A
YES
2.TGC 1.8M
200W
1.83M
42
TGC 3.5M
N/A
YES
2.TGC 3.5M
200W
3.51M
43
TGC 5M
N/A
YES
2.TGC 5M
200W
5.3M
44
TGC 7M
N/A
YES
2.TGC 7M
200W
7.01M
USB
USB
59
TS-480HX/480SAT
ADJUSTMENT
No.
Adjustment Item
Apply 100W
Apply 200W
Display
Item
Frequency
Mode
USB
45
TGC 10M
N/A
YES
2.TGC 10M
200W
10.1M
46
TGC 14M
N/A
YES
2.TGC 14M
200W
14.1M
47
TGC 18M
N/A
YES
2.TGC 18M
200W
18.1M
48
TGC 21M
N/A
YES
2.TGC 21M
200W
21.1M
49
TGC 24.9M
N/A
YES
2.TGC 24M
200W
24.9M
50
TGC 28M
N/A
YES
2.TGC 28M
200W
29.1M
51
TGC 50M
N/A
YES
2.TGC 50M
100W
51.9M
52
ALC Meter
YES
YES
ALC.START
Start
14.1M
USB
53
YES
YES
ALC.MAX
Zone Max
54
CW CAR Level
YES
YES
CAR.LEVEL
Zone Max
14.1M
CW
55
AM CAR Level
YES
YES
CAR.LEVEL
MOD 80% (100W)
14.1M
AM
14.1M
USB
14.1M
USB
MOD 75% (200W)
56
PGC
57
YES
N/A
PGC 50W
50W
YES
N/A
PGC 25W
25W
58
YES
N/A
PGC 10W
10W
59
YES
YES
PGC 5W
5W
60
N/A
YES
2.PGC 100
100W
61
200W PGC
N/A
YES
2.PGC 50
50W
62
N/A
YES
2.PGC 25
25W
63
N/A
YES
2.PGC 10
10W
64
FM Modulator
N/A
N/A
MOD.BIAS
Wide
29.1M
FM
65
FM Dev.
YES
YES
DEV.WIDE
Wide
29.1M
FM
3.51M
USB
USB
66
67
YES
YES
DEV.NAROW
Narrow
Current Protection
YES
N/A
CURRENT1
DC1:21A
N/A
YES
CURRENT2
DC1:21A, DC2:21A
CAR Point
YES
YES
CAR.POINT
10.695M
14.1M
68
69
70
YES
YES
CAR.POINT
10.695M
14.1M
LSB
CAR Suppression
YES
YES
SUPPRESS
USB
14.1M
USB
YES
YES
SUPPRESS
LSB
14.1M
LSB
73
SWR Protection
YES
YES
SWR PRO
HF
14.1M
CW
74
SWR Meter
YES
YES
HF SWR
14M
14.1M
CW
75
(SWR : 3)
YES
YES
50M SWR
50M
51.9M
FM
76
EEPROM Write
YES
YES
WRITE ROM
77
CheckSum
YES
YES
CHECKSUM
78
Display check
YES
YES
71
72
• You can confirm the settings of Menu No.77 even if you
are not in the adjustment mode.
• Turn the transceiver ON while pressing the [MIC] key and
[NR] key, to enter checksum confirmation mode.
• The checksum of the main microcomputer and the panel
microcomputer alternates on the display.
• The checksum value of the main microcomputer appears
on the 7 segment display while [M-CHKSUM] appears on
the 13 segment display.
• The checksum value of the panel microcomputer appears
on the 7 segment display while [P-CHKSUM] appears on
the 13 segment display.
60
■ Menu No. 77 checksum display
Main microcomputer
Panel microcomputer
The checksum of
the main microcomputer and the
panel microcomputer alternates
on the display.
TS-480HX/480SAT
ADJUSTMENT
Display Check
Measurement
Item
Condition
1. Setting and
full reset
1) Connect the DC cord to the
DC power supply.
• TS-480HX
DC IN1 and DC IN2 : DC 13.8V
• TS-480SAT
DC IN1 : DC 13.8V
Testequipment
Unit
Terminal
2) Full reset
Turn the transceiver ON by
pressing the power switch
while the [A=B] key is pressed,
then press the [A=B] key again
when the reset confirmation
message appears.
2. LCD all
segments
light
Adjustment
Unit
Parts
Remote LCD
control
panel
(front)
1) Menu No. : 78
Method
Specifications/Remarks
After displaying
“HELLO”, the
display is reset as
follows;
DISP f. : 14.000.00
Mode : USB
Meter : ALC
ANT : 1
AGC
PRE
Display should be normal.
Should be at the reset
frequency.
Check
LCD all segments light.
PLL Section
Measurement
Item
Condition
Testequipment
Unit
1. LO2
(62.4MHz)
frequency
1) Display f. : 14.200MHz
Mode : USB
Disconnect the cable from
CN1 and insert a cable from
the frequency counter.
After the adjustment,
connect the cable to CN1.
f. counter TX-RX
(A/2)
2. LO2 level
1) Display f. : 14.200MHz
Mode : USB
Disconnect the cable from
CN1 and insert a cable from
the oscilloscope.
After the adjustment,
connect the cable to CN1.
Spectrum
analyzer
3. Lock voltage 1) VCO1
Display f. : 15.999MHz
Mode : USB
Display f. : 30.000kHz
DC V.M
Terminal
CN1
(LO2)
CV
Adjustment
Unit
TX-RX
(A/2)
TX-RX
(A/2)
Parts
Method
TC1
62.40000MHz
± 30Hz
Note : If the SO-3 is installed
in the transceiver, do not
make the LO2 (62.4MHz)
frequency adjustment.
L6
L9
Level max.
–13dBm or more
TC452 4.20V
Check
2) VCO2
Display f. : 35.999MHz
Mode : USB
Display f. : 16.000MHz
TX-RX
(A/2)
3) VCO3
Display f. : 59.999MHz
Mode : USB
Display f. : 36.000MHz
TX-RX
(A/2)
Specifications/Remarks
TC451 4.20V
Check
TC453 4.05V
Check
± 0.05V
0.2~1.0V
± 0.05V
0.2~1.0V
± 0.05V
0.2~1.0V
61
TS-480HX/480SAT
ADJUSTMENT
Receiver Section
Measurement
Item
Condition
Testequipment
Unit
Terminal
Adjustment
Unit
Parts
Method
Specifications/Remarks
• Perform the following in the adjustment mode. Item 1, 4, 6 and 10~17.
To terminate the adjustment menu in the middle, save your settings with Menu No. 76.
1. IF SHIFT VR 1) Menu No. : 00
center
(14.2MHz, USB)
voltage
IF SHIFT knob : Center
Remote [ ] or
control [ ]
panel
(front)
RF
L166
L167
L168
2. MCF
1) Display f. : 29.200MHz
(73.095MHz)
Mode : FM
Spectrum analyzer setting
Center f. : 73.095MHz
Frequency span : 100kHz
XdB/DIV : 10dB
RBW : 30kHz
VBW : 30kHz
3. Trap
1) Display f. : 11.700MHz
frequency
Mode : AM
(TS-480HX
PRE-AMP : ON
E type only)
AGC : FAST
• 11.7MHz
SSG f. : 11.700MHz
SSG output : –115dBm (0.398µV)
MOD : 1kHz
DEV : 60%
• 15.5MHz
2) Display f. : 15.500MHz
Mode : USB
PRE-AMP : ON
AGC : FAST
SSG f. : 15.501MHz
SSG output : –115dBm (0.398µV)
4. AGC
1) Menu No. : 01
reference
(14.2MHz, USB)
voltage
Tracking
generator
DC V.M
TX-RX
(A/2)
5. RF IF gain
SSG
TX/RX ANT1
unit rear
panel
6. AGC start
level
• 14M
1) Display f. : 14.200MHz
Mode : USB
PRE-AMP : ON
AGC : FAST
AF output : 0.63V/8Ω
SSG f. : 14.201MHz
SSG output : –115dBm (0.398µV)
1) Menu No. : 02
(14.2MHz, USB)
SSG f. : 14.201MHz
SSG output : OFF
2) SSG output : –109dBm (0.794µV)
Spectrum RF
analyzer
1 push
Adjust the coils to
obtain the frequency
response as shown.
73.095
TP1
(CN152)
TP2
(CN252)
SSG
TX/RX ANT1
unit rear
panel
AF V.M
TX/RX EXT.SP
unit front
panel
15kHz
(MHz)
TC51
AF output min.
TC52
AGC
Remote
control
panel
(front)
TX-RX
(A/2)
[ ] or
[ ]
L553
L554
Set the adjustment 2.8V± 0.1V
value within the
limit of the specified
voltage.
AF output max.
Oscilloscope TX/RX EXT.SP
AF V.M
unit front
DM.SP
panel
Remote [ ] or
control [ ]
panel
(front)
Check the adjustment value (A) displayed on the left
side of the display.
02
033 040
A
Change the adjustment value (B) displayed on the
right side of the display by pressing the [ ] or [ ]
keys so that adjustment value (A) increace by 3
(A+3).
02
036 040
A+3
• 50M
3) Menu No. : 10
(50.2MHz, USB)
SSG f. : 50.201MHz
SSG output : OFF
4) SSG output : –113dBm (0.501µV)
10
037 044
C
Change the adjustment value (D) displayed on the
right side of the display by pressing the [ ] or [ ]
keys so that adjustment value (C) increace by 3
(C+3).
10
040 044
C+3
62
B
Check the adjustment value (C) displayed on the left
side of the display.
D
TS-480HX/480SAT
ADJUSTMENT
Measurement
Item
Condition
7. FM
1) Display f. : 29.200MHz
discriminator
Mode : FM
AF output : 0.63V/8Ω
SSG f. : 29.200MHz
SSG output : –53dBm (501µV)
MOD : 1kHz
DEV : 3kHz
8. AF output
1) Display f. : 29.200MHz
Mode : FM
SSG f. : 29.200MHz
SSG output : –53dBm (501µV)
MOD : 1kHz
DEV : 3kHz
AF distortion : 10%
9. S/N
• 550kHz
1) Display f. : 550kHz
Mode : AM
PRE-AMP : ON
AGC : FAST
AF output : 0.63V/8Ω
SSG f. : 550kHz
SSG output : –79dBm (25µV)
MOD : 1kHz
DEV : 60%
2) DEV : OFF
3) Display f. : 14.200MHz
Mode : USB
PRE-AMP : ON
AGC : FAST
AF output : 0.63V/8Ω
SSG f. : 14.201MHz
SSG output : –120dBm (0.22µV)
4) SSG output : OFF
5) Display f. : 14.200MHz
Mode : USB
PRE-AMP : ON
AGC : FAST
AF output : 0.63V/8Ω
SSG f. : 14.201MHz
SSG output : –114dBm (0.446µV)
6) PRE-AMP : OFF
7) Display f. : 14.200MHz
Mode : USB
ATT : OFF
AGC : FAST
AF output : 0.2V/8Ω
SSG f. : 14.201MHz
SSG output : –107dBm (1µV)
8) ATT : ON
9) Display f. : 28.200MHz
Mode : USB
PRE-AMP : ON
AGC : FAST
AF output : 0.63V/8Ω
SSG f. : 28.201MHz
SSG output : –124dBm (0.141µV)
10) SSG output : OFF
• 14.2MHz
• PRE-AMP
gain
• RF ATT
• 28.2MHz
Testequipment
SSG
Unit
Terminal
TX/RX ANT1
unit rear
panel
Oscilloscope TX/RX EXT.SP
AF V.M
unit front
Distortion panel
meter
DM.SP
Audio
analyzer
Adjustment
Unit
TX-RX
(A/2)
Parts
L551
Method
Specifications/Remarks
AF distortion min.
1.4% or less
Check
2.1W or more
Check
–10dB or less
Check
Set SINAD at 0dB.
–10dB or less
Check for SINAD
–(5~15)dB
Set AF level at 0dB.
Check for AF level
–(9~15)dB
Check
–10dB or less
63
TS-480HX/480SAT
ADJUSTMENT
Measurement
Item
Condition
• 52.2MHz
11) Display f. : 52.200MHz
Mode : FM
PRE-AMP : ON
AF output : 0.63V/8Ω
SSG f. : 52.200MHz
SSG output : –119dBm (0.25µV)
MOD : 1kHz
DEV : 3kHz
10. HF SSB
S-meter
• S1
• S9
1) Menu No. : 03
(14.2MHz, USB)
SSG f. : 14.201MHz
SSG output : –107dBm (1µV)
2) Menu No. : 04
(14.2MHz, USB)
SSG output : –81dBm (19.9µV)
• Full scale 3) Menu No. : 05
(Lights up all)
(14.2MHz, USB)
SSG output : –21dBm (19.9mV)
11. HF FM
S-meter
• S1
1) Menu No. : 06
(29.2MHz, FM)
SSG f. : 29.200MHz
SSG output : –117dBm (0.316µV)
MOD : 1kHz
DEV : 3kHz
• Full scale 2) Menu No. : 07
(Lights up all)
(29.2MHz, FM)
SSG output : –95dBm (3.98µV)
12. 50M
1) Menu No. : 11
SSB S-meter
(50.2MHz, USB)
• S1
SSG f. : 50.201MHz
SSG output : –111dBm (0.63µV)
• S9
2) Menu No. : 12
(50.2MHz, USB)
SSG output : –85dBm (12.6µV)
• Full scale 3) Menu No. : 13
(Lights up all)
(50.2MHz, USB)
SSG output : –25dBm (12.6mV)
13. 50M
FM S-meter
• S1
1) Menu No. : 14
(50.2MHz, FM)
SSG f. : 50.2MHz
SSG output : –117dBm (0.316µV)
MOD : 1kHz
DEV : 3kHz
• Full scale 2) Menu No. : 15
(Lights up all)
(50.2MHz, FM)
SSG output : –95dBm (3.98µV)
14. HF FM SQL 1) Menu No. : 08
threshold
(29.2MHz, FM)
SSG output : OFF
MOD : 1kHz
DEV : 3kHz
64
Testequipment
SSG
Unit
Terminal
Adjustment
Unit
Parts
TX/RX ANT1
unit rear
panel
Oscilloscope TX/RX EXT.SP
AF V.M
unit front
Distortion panel
meter
DM. SP
Audio
analyzer
Remote [ ] or
control [ ]
panel
(front)
Method
Specifications/Remarks
Check
12dB SINAD or more
1 push
S-meter lights up to S1 level.
S-meter lights up to S9 level.
S-meter lights up all.
S-meter lights up to S1 level.
S-meter lights up all.
S-meter lights up to S1 level.
S-meter lights up to S9 level.
S-meter lights up all.
S-meter lights up to S1 level.
S-meter lights up all.
TS-480HX/480SAT
ADJUSTMENT
Measurement
Item
Condition
Testequipment
15. HF FM SQL 1) Menu No. : 09
SSG
thigh
(29.2MHz, FM)
SSG f. : 29.200MHz
SSG output : –113dBm (0.501µV)
Oscilloscope
MOD : 1kHz
DEV : 3kHz
AF V.M
DM. SP
16. 50M
1) Menu No. : 16
FM SQL
(50.2MHz, FM)
threshold
SSG output : OFF
MOD : 1kHz
DEV : 3kHz
17. 50M
FM SQL
tight
Unit
Terminal
TX/RX ANT1
unit rear
panel
Adjustment
Unit
Parts
Remote [ ] or
control [ ]
panel
(front)
Method
Specifications/Remarks
1 push
TX/RX EXT.SP
unit front
panel
1) Menu No. : 17
(50.2MHz, FM)
SSG f. : 50.200MHz
SSG output : –113dBm (0.501µV)
MOD : 1kHz
DEV : 3kHz
• Writing data : After items 1, 4, 6 and 10~17 have been adjusted;
1) Menu No. : 76
2) [ ] or [ ] key : Push once time. Display “rEAdy” → “good” (If “nG” is displayed, enter data again.)
3) [MTR] key : Push once time.
18. NB gain
1) Display f. : 14.200MHz
DC V.M
Mode : USB
PRE-AMP : ON
SSG
AGC : FAST
NB : ON
SSG f. : 14.201MHz
SSG output : –103dBm (1.58µV) Oscilloscope
AF V.M
DM.SP
2) NB : OFF→ON
19. VGS-1
(Option)
1) Disconnect the antenna cable
from the transceiver.
Connect the VGS-1 to CN390
on the TX-RX unit (A/2).
Display f. : 13.900MHz
Mode : USB
AF knob : MIN
2) Connect a microphone to
the MIC jack.
TX-RX NB
(A/2)
TX/RX ANT1
unit rear
panel
TX-RX
(A/2)
L506
L507
Voltage min.
TX/RX EXT.SP
unit front
panel
Noise G.
Remote [PF]
control
panel
(front)
[CH1]
Adjust output of
noise generator to
S5, and check.
Noise should disappear when
NB is on.
1 push
The display frequency can be
heard vocally.
Hold down [CH1]
key, and talk into
the microphone for
approximately
5 seconds.
Press the [CH1] key The recorded voice message
again.
is played back.
65
TS-480HX/480SAT
ADJUSTMENT
Transmitter Section (TS-480HX)
Measurement
Item
1. Final idling
current
Condition
1) Display f. : 14.100MHz
Mode : USB
Final unit (A/3)
VR1, 2, 3, 801 : MIN
VR802 : MAX
Transmit
Testequipment
Ammeter
Unit
Terminal
TX/RX DC IN1
unit rear DC IN2
panel
Adjustment
Unit
Parts
Final
(A/3)
Method
Specifications/Remarks
Check the default
current (I2) of
DC IN2.
VR1
I2 + 300mA
= IA (at DC IN2)
VR2
IA + 500mA
= IB (at DC IN2)
± 20mA
Check the default
current (I1) of DC IN1.
VR3
I1 + 500mA (at DC IN1) ± 20mA
VR801 IB + 500mA (at DC IN2)
2. Current
protection
pre-adjust
1) Display f. : 14.100MHz
Mode : USB
Transmit
DC V.M
TX-RX
(A/2)
VR1 (IP1) TX-RX
(A/2)
VR2 (IP2)
VR1
Voltage min.
100mV or less
VR2
• Perform the following in the adjustment mode. Item 3~18.
To terminate the adjustment menu in the middle, save your settings with Menu No. 76.
3. ALC
reference
voltage
1) Menu No. : 18
(14.1MHz, USB)
Transmit
DC V.M
TX-RX
(A/2)
ALC
4. Drive output 1) Menu No. : 24
level
(14.1MHz, USB)
Disconnect the cable from
CN1 and insert a cable from
the spectrum analyzer.
Transmit
After check, connect the
cable to CN1.
Spectrum RF
analyzer
5. Null
1) Menu No. : 26
(14.1MHz, USB)
Transmit
6. HF power
• POC 5W
1) Menu No. : 23
(14.1MHz, USB)
Transmit
2) Menu No. : 29
(14.1MHz, USB)
Transmit
3) Menu No. : 28
(14.1MHz, USB)
Transmit
4) Menu No. : 27
(14.1MHz, USB)
Transmit
5) Menu No. : 26
(14.1MHz, USB)
Transmit
6) Menu No. : 24
(14.1MHz, USB)
Transmit
Power meter TX/RX ANT1
250W ATT unit rear
panel
DC V.M
TX-RX VSR
(A/2)
Power meter TX/RX ANT1
250W ATT unit rear
panel
• 2POC
10W
• 2POC
25W
• 2POC
50W
• 2POC
100W
• 2POC
200W
66
Remote [ ] or
control [ ]
panel
(front)
CN1
(DRV)
Set the adjustment 2.6V± 0.1V
value wiithin the
limit of the specified
voltage.
Check
Final
(C/3)
TC501 VSR voltage min.
Remote [ ] or
control [ ]
panel
(front)
3dBm or more
0.3V or less
Set the adjustment 5.7W± 0.5W
value within the
limit of the specified
power.
12W± 0.5W
27W± 1.0W
53W± 2.0W
105W± 5.0W
205W± 5.0W
TS-480HX/480SAT
ADJUSTMENT
Measurement
Item
Condition
7. Band 2TGC
(HF)
• 1.8M
• 3.5M
1) Menu No. : 41
(1.83MHz, USB)
Transmit
2) Menu No. : 42
(3.51MHz, USB)
Transmit
• 5M
3) Menu No. : 43
(5.30MHz, USB)
Transmit
• 7M
4) Menu No. : 44
(7.01MHz, USB)
Transmit
• 10M
5) Menu No. : 45
(10.1MHz, USB)
Transmit
• 14M
6) Menu No. : 46
(14.1MHz, USB)
Transmit
• 18M
7) Menu No. : 47
(18.1MHz, USB)
Transmit
• 21M
8) Menu No. : 48
(21.1MHz, USB)
Transmit
• 24M
9) Menu No. : 49
(24.9MHz, USB)
Transmit
• ODP
10) Menu No. : 50
(Over drive
(29.1MHz, USB)
protection)
Transmit
• 28M
11) Menu No. : 50
(29.1MHz, USB)
Transmit
12) Menu No. : 50
(29.1MHz, USB)
Transmit
8. Power 2PGC 1) Menu No. : 60
• 100W
(14.1MHz, USB)
Transmit
• 50W
2) Menu No. : 61
(14.1MHz, USB)
Transmit
• 25W
3) Menu No. : 62
(14.1MHz, USB)
Transmit
Testequipment
Unit
Terminal
Power meter TX/RX ANT1
250W ATT unit rear
panel
Adjustment
Unit
Parts
Remote [ ] or
control [ ]
panel
(front)
Final
(A/3)
Method
Specifications/Remarks
The Band 2TGC
200W± 10W
adjustment must
increase the power
from a value smaller
than the target
transmitting power.
To do this, first
increace the adjustment value to reduce
the transmitting
power, then decreace
the adjustment value
to become within the
limits of the target
transmitting power.
Set the adjustment 215W± 7.0W
value within the
limit of the specified
power.
VR802 205W
± 2.0W
Remote [ ] or
control [ ]
panel
(front)
The Band 2TGC
200W± 10W
adjustment must
increase the power
from a value smaller
than the target
transmitting power.
To do this, first
increace the adjustment value to reduce
the transmitting
power, then decreace
the adjustment value
to become within the
limits of the target
transmitting power.
Set the adjustment 105W± 5.0W
value within the
limit of the specified
power.
55W± 2.0W
27.5W± 1.0W
67
TS-480HX/480SAT
ADJUSTMENT
Measurement
Item
Condition
• 10W
4) Menu No. : 63
(14.1MHz, USB)
Transmit
• 5W
5) Menu No. : 59
(14.1MHz, USB)
Transmit
9. Band 2TGC
(50M)
Testequipment
Unit
Terminal
Power meter TX/RX ANT1
250W ATT unit rear
panel
Adjustment
Unit
Parts
Remote [ ] or
control [ ]
panel
(front)
Method
Set the adjustment 12.5W± 0.5W
value within the
limit of the specified
power.
7.5W± 0.5W
1) Menu No. : 51
(51.9MHz, USB)
Transmit
105W± 5.0W
10. ALC meter 1) Menu No. : 52
• Start point
(14.1MHz, USB)
Transmit
[ ]
1 push
• Zone max. 2) Menu No. : 53
(14.1MHz, USB)
Transmit
11. FM DEV
• Wide
1) Menu No. : 65
(29.1MHz, FM)
Transmit
• Narrow
2) Menu No. : 66
(29.1MHz, FM)
Transmit
12. Carrier
point
• USB
1) Menu No. : 69
(14.1MHz, USB)
Transmit
• LSB
2) Menu No. : 70
(14.1MHz, LSB)
Transmit
13. AM carrier
level
1) Menu No. : 55
(14.1MHz, AM)
MIC input
AG : OFF
Transmit
1) Menu No. : 54
(14.1MHz, CW)
Transmit
15. Carrier
suppresion
• USB
1) Menu No. : 71
(14.1MHz, USB)
Transmit
• LSB
68
2) Menu No. : 72
(14.1MHz, LSB)
Transmit
ALC meter lights up to 1.
ALC meter zone max.
Power meter
Linear
detector
250W ATT
[ ] or
[ ]
4.3kHz
According to the
larger +, –.
± 0.1kHz
2.15kHz
According to the
larger +, –.
Oscilloscope
250W ATT
Change the adjustment values to get
the waveform
as shown.
OK
NG
Power meter
250W ATT
Liner
detector
AG
2) MIC input
AG : 1kHz/10mV
Transmit
14. CW carrier
level
Specifications/Remarks
Check for ALC
meter.
Remote [ ] or
control [ ]
panel
(front)
1 dot or more
Set the adjustment 75%± 5%
value within the
limit of the specified
modulation.
Set the adjustment ALC meter lights up to 6.
value within the
(ALC meter zone max. + 1 dot)
limit of the specified
ALC meter.
Spectrum TX/RX ANT1
analyzer
unit rear
250W ATT panel
TX-RX
(A/2)
VR621 Carrier level min.
VR622
Check
50dB or more
TS-480HX/480SAT
ADJUSTMENT
Measurement
Item
16. Current
protection
17. SWR
protection
Condition
Testequipment
Unit
Terminal
Adjustment
Unit
Method
Specifications/Remarks
1) Menu No. : 68
(3.51MHz, USB)
Transmit
Power meter TX/RX ANT1
250W ATT unit rear
panel
Remote [ ] or
control [ ]
panel
(front)
Set the adjustment 220W± 5W
value within the
limit of the specified
power.
2) Menu No. : 68
(3.51MHz, USB)
Transmit
DC V.M
TX-RX
(A/2)
2.25V
1) Menu No. : 73
(14.1MHz, CW)
Transmit
150Ω
TX/RX ANT1
dummy load unit rear
Through type panel
power meter
250W ATT
TX-RX
(A/2)
IP3
IP4
VR1
± 0.25V
VR2
Remote [ ] or
control [ ]
panel
(front)
18. SWR meter 1) Menu No. : 74
• 14M
(14.1MHz, CW)
(SWR : 3)
Transmit
• 50M
(SWR : 3)
Parts
[ ]
Set the adjustment 80W± 2W
value within the
limit of the specified
power.
1 push
SWR meter lights up to 3
position.
2) Menu No. : 75
(51.9MHz, FM)
Transmit
• Writing data : After items 3~18 have been adjusted;
1) Menu No. : 76
2) [ ] or [ ] key : Push once time. Display “rEAdy” → “good” (If “nG” is displayed, enter data again.)
3) [MTR] key : Push once time.
Transmitter Section (TS-480SAT)
Measurement
Item
1. Final idling
current
2. Current
protection
pre-adjust
Condition
1) Display f. :14.100MHz
Mode : USB
Final unit (A/3)
VR1 : MIN
VR2, 3 : Center
Transmit
1) Display f. : 14.100MHz
Mode : USB
Transmit
Testequipment
Ammeter
DC V.M
Unit
Terminal
TX/RX DC IN1
unit rear
panel
TX-RX
(A/2)
VR2
(IP2)
Adjustment
Unit
Parts
Final
(A/3)
TX-RX
(A/2)
Method
Specifications/Remarks
Check the default
current (I1) of
DC IN1.
VR1
I1 + 300mA = IA
VR2
IA + 600mA = IB
VR3
IB + 500mA
VR2
Voltage min.
± 20mA
100mV or less
• Perform the following in the adjustment mode. Item 3~19.
To terminate the adjustment menu in the middle, save your settings with Menu No. 76.
3. ALC
reference
voltage
1) Menu No. : 18
(14.1MHz, USB)
Transmit
DC V.M
TX-RX
(A/2)
ALC
Remote [ ] or
control [ ]
panel
(front)
Set the adjustment 2.6V± 0.1V
value wiithin the
limit of the specified
voltage.
69
TS-480HX/480SAT
ADJUSTMENT
Measurement
Item
Condition
Testequipment
Unit
Terminal
Adjustment
Unit
Parts
Spectrum RF
analyzer
5. Null
1) Menu No. : 19
(14.1MHz, USB)
Final unit (C/3)
VR501 : MAX
Transmit
Power meter TX/RX ANT1
150W ATT unit rear
panel
6. HF power
POC
• 5W
1) Menu No. : 23
(14.1MHz, USB)
Transmit
Power meter TX/RX
ANT1
150W ATT unit rear
panel
• 10W
2) Menu No. : 22
(14.1MHz, USB)
Transmit
• 25W
3) Menu No. : 21
(14.1MHz, USB)
Transmit
26W± 1.0W
• 50W
4) Menu No. : 20
(14.1MHz, USB)
Transmit
52W± 2.0W
• 100W
5) Menu No. : 19
(14.1MHz, USB)
Transmit
104W± 2.0W
7. Band TGC
(HF)
• 1.8M
1) Menu No. : 30
(1.83MHz, USB)
Transmit
• 3.5M
2) Menu No. : 31
(3.51MHz, USB)
Transmit
• 5M
3) Menu No. : 32
(5.30MHz, USB)
Transmit
• 7M
4) Menu No. : 33
(7.01MHz, USB)
Transmit
The Band TGC
100W± 5.0W
adjustment must
increase the power
from a value smaller
than the target
transmitting power.
To do this, first
increace the adjustment value to reduce
the transmitting
power, then decreace
the adjustment value
to become within the
limits of the target
transmitting power.
• 10M
5) Menu No. : 34
(10.1MHz, USB)
Transmit
• 14M
6) Menu No. : 35
(14.1MHz, USB)
Transmit
70
TX-RX
(A/2)
Check
Specifications/Remarks
4. Drive output 1) Menu No. : 19
level
(14.1MHz, USB)
Disconnect the cable from
CN1 and insert a cable from
the spectrum analyzer.
Transmit
After check, connect the
cable to CN1.
DC V.M
CN1
(DRV)
Method
Final
(C/3)
TC501 VSR voltage min.
3dBm or more
0.2V or less
VSR
Remote [ ] or
control [ ]
panel
(front)
Set the adjustment 5.7W± 0.3W
value within the
limit of the specified
power.
11W± 0.5W
TS-480HX/480SAT
ADJUSTMENT
Measurement
Item
Condition
• 18M
7) Menu No. : 36
(18.1MHz, USB)
Transmit
• 21M
8) Menu No. : 37
(21.1MHz, USB)
Transmit
• 24M
9) Menu No. : 38
(24.9MHz, USB)
Transmit
• 28M
10) Menu No. : 39
(29.1MHz, USB)
Transmit
8. Power PGC
• 50W
• 25W
• 10W
• 5W
Testequipment
Unit
Terminal
Power meter TX/RX ANT1
150W ATT unit rear
panel
Adjustment
Unit
Parts
Remote [ ] or
control [ ]
panel
(front)
1) Menu No. : 56
(14.1MHz, USB)
Transmit
Method
The Band TGC
100W± 5.0W
adjustment must
increase the power
from a value smaller
than the target
transmitting power.
To do this, first
increace the adjustment value to reduce
the transmitting
power, then decreace
the adjustment value
to become within the
limits of the target
transmitting power.
Set the adjustment 50W± 2.0W
value within the
limit of the specified
power.
25W± 1.0W
2) Menu No. : 57
(14.1MHz, USB)
Transmit
3) Menu No. : 58
(14.1MHz, USB)
Transmit
4) Menu No. : 59
(14.1MHz, USB)
Transmit
10W± 0.5W
5W± 0.3W
9. Band TGC
(50M)
1) Menu No. : 40
(51.9MHz, USB)
Transmit
10. TX power
1) Menu No. : 75
(51.9MHz, FM)
VR501 : Center
Transmit
11. ALC meter 1) Menu No. : 52
• Start point
(14.1MHz, USB)
Transmit
• Zone max. 2) Menu No. : 53
(14.1MHz, USB)
Transmit
12. FM DEV
• Wide
1) Menu No. : 65
(29.1MHz, FM)
Transmit
• Narrow
2) Menu No. : 66
(29.1MHz, FM)
Transmit
13. Carrier
point
• USB
1) Menu No. : 69
(14.1MHz, USB)
Transmit
• LSB
2) Menu No. : 70
(14.1MHz, LSB)
Transmit
Specifications/Remarks
100W± 5.0W
Final
(C/3)
VR501 98W
Remote [ ]
control
panel
(front)
Power meter
Linear
detector
150W ATT
[ ] or
[ ]
1 push
± 1W
ALC meter lights up to 1.
ALC meter zone max.
4.3kHz
According to the
larger +, –.
± 0.1kHz
2.15kHz
According to the
larger +, –.
Oscilloscope
150W ATT
Change the adjustment values to get
the waveform
as shown.
OK
NG
71
TS-480HX/480SAT
ADJUSTMENT
Measurement
Item
14. AM carrier
level
Condition
1) Menu No. : 55
(14.1MHz, AM)
MIC input
AG : OFF
Transmit
Testequipment
Unit
Terminal
1) Menu No. : 54
(14.1MHz, CW)
Transmit
16. Carrier
suppresion
• USB
1) Menu No. : 71
(14.1MHz, USB)
Transmit
• LSB
17. Current
protection
18. SWR
protection
Unit
Method
Check for ALC
meter.
Remote [ ] or
control [ ]
panel
(front)
Spectrum
analyzer
150W ATT
TX-RX
(A/2)
50dB or more
Check
1) Menu No. : 67
(3.51MHz, USB)
Transmit
Power meter
250W ATT
2) Menu No. : 67
(3.51MHz, USB)
Transmit
DC V.M
1) Menu No. : 73
(14.1MHz, CW)
Transmit
150Ω
TX/RX ANT1
dummy load unit rear
Through type panel
power meter
150W ATT
TX-RX
(A/2)
IP4
Remote [ ] or
control [ ]
panel
(front)
Set the adjustment 110W± 2W
value within the
limit of the specified
power.
TX-RX
(A/2)
2.25V
VR2
Remote [ ] or
control [ ]
panel
(front)
[ ]
1 push
2) Menu No. : 75
(51.9MHz, FM)
Transmit
Oscilloscope TX-RX
Power meter (A/2)
AMD
Final
(C/3)
± 0.25V
Set the adjustment 40W± 1W
value within the
limit of the specified
power.
• Writing data : After items 3~19 have been adjusted;
1) Menu No. : 76
2) [ ] or [ ] key : Push once time. Display “rEAdy” → “good” (If “nG” is displayed, enter data again.)
3) [MTR] key : Push once time.
72
1 dot or more
Set the adjustment 80%± 5%
value within the
limit of the specified
modulation.
VR621 Carrier level min.
VR622
2) Menu No. : 72
(14.1MHz, LSB)
Transmit
20. AT detection 1) Display f. : 51.9MHz
balance
Mode : FM
Power : 10W
Transmit
Specifications/Remarks
Set the adjustment ALC meter lights up to 6.
value within the
(ALC meter zone max. + 1 dot)
limit of the specified
ALC meter.
19. SWR meter 1) Menu No. : 74
• 14M
(14.1MHz, CW)
(SWR : 3)
Transmit
• 50M
(SWR : 3)
Parts
Power meter TX/RX ANT1
150W ATT unit rear
Liner
panel
detector
AG
2) MIC input
AG : 1kHz/10mV
Transmit
15. CW carrier
level
Adjustment
VR502 Turn the VR502 to
the point where the
waveform on the
oscilloscope
changes from high
to low.
(Threshold point)
SWR meter lights up to 3
position.
TS-480HX/480SAT
ADJUSTMENT
Adjustment Points (Upper Side)
TC501
VR501
FINAL UNIT (C/3) : TS-480HX
TC501 : Null
TC501
FINAL UNIT (C/3) : TS-480SAT
VR501 : TX power
VR502 : AT detection balance
TC501 : Null
TS-480SAT
TS-480HX
FINAL UNIT
(X45-365) (C/3)
FINAL UNIT
(X45-366) (C/3)
VR502
TC1
AMD
VSR
L6
VR622
CV
L9
L551
VR621
AGC
TC453
TC452
TC451
L554
L553
CN1
LO2
(WHITE)
ALC
IP4
IP3
TX-RX UNIT
(X57-663) (A/2)
IP1
IP2
CN390 VR1 VR2
L506
NB
J731
EXT. SP
TX-RX UNIT (A/2)
TC1 : LO2 (62.4MHz) frequency
L6,9 : LO2 level
TC451 : Lock voltage (VCO2)
TC452 : Lock voltage (VCO1)
TC453 : Lock voltage (VCO3)
L507
FRONT
L553,554 : RF IF gain
L551 : FM discriminator
L506,507 : NB gain
VR1,2 : Current protection
VR621,622 : Carrier suppresion
73
TS-480HX/480SAT
ADJUSTMENT
Adjustment Points (Lower Side) : TS-480HX
FINAL UNIT
(X45-366) (A/3)
VR3
VR1
VR2
VR802
CN1
DRV
VR801
RF UNIT
(X44-327)
L166 L167 L168
TC51
CN252
TP2
TC52
CN152
TP1
FINAL UNIT (A/3)
VR1,2,3,801 : Final idling current
VR802 : ODP (Over Drive Protection)
74
FRONT
RF UNIT
L166,167,168 : MCF (73.095MHz)
TC51 : Trap frequency (11.7MHz)
TC52 : Trap frequency (15.5MHz)
TS-480HX/480SAT
ADJUSTMENT
Adjustment Points (Lower Side) : TS-480SAT
VR3
VR1
VR2
CN1
DRV
RF UNIT
(X44-327)
FINAL UNIT
(X45-365) (A/3)
L166 L167 L168
TC51
CN252
TP2
TC52
CN152
TP1
FINAL UNIT (A/3)
VR1,2,3 : Final idling current
FRONT
RF UNIT
L166,167,168 : MCF (73.095MHz)
TC51 : Trap frequency (11.7MHz)
TC52 : Trap frequency (15.5MHz)
75
TS-480HX/480SAT
INTERCONNECTION DIAGRAM
PADDLE
KEY
E11-0455-05
E11-0455-05
GND
GND
1
3
11
10
2
J301
NC
KEY
GND
DASH
KYS
NC
DOT
1
3
11
10
2
1.0mm Pitch
CN309
E40-5978-05
GND
KEY
DASH
DOT
KYS
AGC
CKYS
PGC
PRES
DATA
CLK
REN
3C
8C
14S
RXB
TXB
GND
J302
FINAL UNIT (FILTER)
X45-365X-XX (B/3) [AT]
0-11:TS-480SAT (K)
2-71:TS-480SAT (E)
RF UNIT
X44-327X-XX
0-00:TS-480HX/480SAT (K)
2-71:TS-480HX/480SAT (E)
X45-366X-XX (B/3) [200W]
0-00:TS-480HX (K)
2-71:TS-480HX (E)
18
CN1
E04-0154-05
DRV
(BLACK)
CN2
E04-0154-05
RAT
RAT
LO2
LO2 (WHITE)
E37-1064-05 (NONE)
CN502
E40-5758-05
12
1.0mm Pitch
12Pin
E37-1070-05
5C
14S
DATA
CLK
FEN2
GND
AMD
PHD
VSF
VSR
TXB
GND
(AT)
1
ATO
PO
ATOUT
(200W)
(NONE)
(AT-TYPE ONLY)
CN505
E04-0190-05
LO1
CN253
E04-0154-05
5C
14S
DATA
CLK
FEN2
GND
GND
GND
VSF
VSR
TXB
GND
E37-1068-05
ATIN
(YELLOW)
(AT-TYPE ONLY)
ATI
ANT2
(RED)
E37-1060-05
LO1 (BLUE)
CN153
E04-0154-05
E37-1062-05
CN503
E04-0190-05
RAT
GND
GND
GND
GND
E37-1063-05
PIN
W101 (200W)
PIN
CN102 (AT)
E04-0154-05
GND
GND
GND
GND
POUT
GND
X45-366X-XX (C/3) [200W]
0-00:TS-480HX (K)
2-71:TS-480HX (E)
GND
CN504
E04-0190-05
ANT1
E37-1067-05
ANT1
FINAL UNIT (ANT)
IF
IF
E37-1061-05
X45-365X-XX (C/3) [AT]
0-11:TS-480SAT (K)
2-71:TS-480SAT (E)
GND
ANT2
10
E37-1105-05 (200W-TYPE)
E37-1061-05 (BLUE)(AT-TYPE)
POUT
GND
50M
10M
4M
14M
28M
7M
2M
21M
GND
LED
1.0mm Pitch
10Pin
E37-1071-05
CN501
E40-5739-05
1
1
JUMPER WIRE
50M
10M
4M
14M
28M
7M
2M
21M
GND
LED
CN101
E40-5734-05
CN254
E04-0154-05
10
18Pin
E37-1069-05
1
1
CN9
E40-3246-05
M
FAN1+
FAN12
CN10
1 E40-3246-05
FAN2+
(200W)
FAN22
M
FAN
FAN
DC
13.8V
GND
EXT.AT
E37-1073-05
1
G
NC 4
2 TT
TS 5
3
G
14S 6
1
14AT
AGND
2
X45-365X-XX (A/3) [AT]
0-11:TS-480SAT (K)
2-71:TS-480SAT (E)
X45-366X-XX (A/3) [200W]
0-00:TS-480HX (K)
2-71:TS-480HX (E)
CN4
E40-5607-05
4
DOUT1
GND
GND
DOUT2
1
SUB UNIT (DRIVE)
X58-4900-XX
-00:TS-480HX (K,E)
-01:TS-480SAT (K,E)
CN3
E40-5608-05
1
DIN1
GND
BIN
GND
DIN2
5
DRV
CN1
E04-0154-05
PO
GND
(200W)
FINAL UNIT
CN2
E40-6078-05
ATEN
ATL5
NC
NC
NC
TXB
NC
NC
CLK
DATA
FEN1
PSC1
TH1
IC1IC1+
FANL
FANH
GND
(AT)
NC
PSC2
IC2+
IC2TH2
TXB
ODP
VDT2
NC
NC
NC
PSC1
TH1
IC1IC1+
FANL
FANH
GND
(200W)
W801(200W)
1
1.0mm Pitch
18Pin
E37-1069-05
18
2.0mm Pitch PH
CN8
E40-3252-05
+B2
+B2
GND
CN11
E04-0154-05
(AT) PO
GND
GND
W1
ATOUT
+B1
CN819
E04-0154-05
DC
13.8V
+B1
E37-1056-05
76
CN820
E04-0154-05
ATIN
E37-1056-05
8Pin
1
14V
14AF
14AG
14S
5V
8C
GND
GND
8
E37-1059-05
TS-480HX/480SAT
INTERCONNECTION DIAGRAM
REMOTE
DATA
E56-0411-05
E56-0405-05
PHONE
EXT.SP
INT.SP
E11-0482-05
MIC
E11-0414-05
COM
E58-0507-05
E37-1072-05
J132
J201
J1
J351
1.SP
2.SPG
MD
NC
MIC
MSG
SS
MCG
8C
MU
8
7
6
5
4
3
2
1
J131
CN2
E40-3237-05
NC
NC
RXD
RTS
TXD
CTS
NC
NC
GND
1
6
2
7
3
8
4
9
5
1
3
11
10
2
4
5
6
SQC
NC
GND
ANO
ANI
DTS
GND
6
4
2
5
1
3
7
J731
SPO
SS
MKE
ALC
COM
RL
BRK
RTK
GND
KEY
DASH
DOT
KYS
AGC
CKYS
PGC
PRES
DATA
CLK
REN
3C
8C
14S
RXB
TXB
GND
1
3
4
6
2
7
5
8
2.SPG
CN403
1 E40-5978-05
1.SPO
E58-0435-05
LCD
NB
B38-0879-05
E37-1058-05
18
IF
CN501
E04-0191-05
LO1
CN3
E04-0191-05
LO2
CN1
E04-0191-05
W501
W502
DISPLAY UNIT
X54-3410-00(A/3)
TX-RX UNIT
X57-663X-XX (A/2)
0-11:TS-480HX (K)
0-12:TS-480SAT (K)
2-71:TS-480HX (E)
2-72:TS-480SAT (E)
J202
E58-0506-05
6
5
4
3
2
1
J2
E58-0506-05
6
5
4
3
2
1
SPG
8M
GND
RDO
TDO
SP
RIT/XIT ENC.
SPG
8M
GND
RDO
TDO
SP
4
5
3
2
1
S34
W02-3662-05
CN375
E40-5758-05
1
MULUT ENC.
/IF SHIFT VR
X54-3410-00(C/3)
5C
14S
DATA
CLK
FEN2
GND
AMD
PHD
VSF
VSR
TXB
GND
CN6
E40-5409-05
CN390
E40-6357-05
1
1. BUSY
2. PLAY
3. SO
4. SI
5. CLK
6. EN
7. USEL
8. RST
9. DGND
10.GND
11.AO
12.AI
13.GND
14.5C
12
VR1
R31-0645-05
VGS-1
AF/SQL VR
X54-3410-00(B/3)
CN7
E40-5409-05
26
CN554
E40-6267-05
1
10
1.5V
2.MEN1
3.MEN2
4.GND
CN5
E40-3239-05
BOARD
to
BOARD
CN901
E40-6266-05
IFIN
GND
8C
TXB
RXB
IFGC
AGC
BLNK
FIL1
FIL2
1
3.GND
8
2.TS
14V
14AF
14AG
14S
5V
8C
GND
GND
CN382
E40-3247-05
CN369
E40-3252-05
1.5V
2.NC
3.SQVL
4.AFVL
5.GND
10
IFIN
GND
8C
TXB
RXB
IFGC
AGC
BLNK
FIL1
FIL2
1.TT
1
12
CN971
E40-6272-05
1
RXOUT
FMIF
RXB
FILT4
FILT3
FILT2
FILT1
TXIN
FILT5
5C
GND
15.6M
12
1
ATEN
PSC2(ATL5)
IC2+
IC2TH2
TXB
ODP
VDT2
CLK
DATA
FEN1
PSC1
TH1
IC1IC1+
FANL
FANH
GND
CN4
E40-5392-05
RXOUT
FMIF
RXB
FILT4
FILT3
FILT2
FILT1
TXIN
FILT5
5C
GND
15.6M
CN555
E40-6273-05
CN359
E40-5978-05
1.5V
2.NC
3.SQVL
4.AFVL
5.GND
OPTION
VR2
R31-0644-05
18
CN3
E40-5392-05
1
TX-RX UNIT (TCXO & BPF)
X57-663X-XX (B/2)
0-11:TS-480HX (K)
0-12:TS-480SAT (K)
2-71:TS-480HX (E)
2-72:TS-480SAT (E)
MAIN
ENCODER
BOARD
to
BOARD
77
PADDLE
KEY
EXT.SP
E11-0455-05
E11-0455-05
E11-0414-05
REMOTE
DATA
E56-0411-05
E56-0405-05
PHONE
INT.SP
E11-0482-05
MIC
COM
E58-0507-05
E37-1072-05
RF UNIT
X44-327X-XX
0-00:TS-480HX/480SAT (K)
2-71:TS-480HX/480SAT (E)
CN1
E04-0154-05
DRV
IF
MD
NC
MIC
MSG
SS
MCG
8C
MU
8
7
6
5
4
3
2
1
CN2
E40-3237-05
NC
NC
RXD
RTS
TXD
CTS
NC
NC
GND
1
6
2
7
3
8
4
9
5
1
3
11
10
2
4
5
6
SQC
NC
GND
ANO
ANI
DTS
GND
6
4
2
5
1
3
7
1.SPO
J201
J351
LCD
NB
B38-0879-05
E37-1058-05
(RED)
IF
CN501
E04-0191-05
LO1
CN3
E04-0191-05
LO2
CN1
E04-0191-05
E37-1060-05
LO1 (BLUE)
LO2 (WHITE)
W501
W502
LO2
DISPLAY UNIT
X54-3410-00(A/3)
(BLACK)
TX-RX UNIT
X57-663X-XX (A/2)
0-11:TS-480HX (K)
0-12:TS-480SAT (K)
2-71:TS-480HX (E)
2-72:TS-480SAT (E)
E37-1064-05 (NONE)
CN502
E40-5758-05
12
1.0mm Pitch
12Pin
E37-1070-05
(AT)
J2
E58-0506-05
6
5
4
3
2
1
SPG
8M
GND
RDO
TDO
SP
RIT/XIT ENC.
SPG
8M
GND
RDO
TDO
SP
4
5
3
2
1
CN6
E40-5409-05
CN390
E40-6357-05
1
1. BUSY
2. PLAY
3. SO
4. SI
5. CLK
6. EN
7. USEL
8. RST
9. DGND
10.GND
11.AO
12.AI
13.GND
14.5C
12
VR1
R31-0645-05
DC
13.8V
GND
E37-1073-05
1
G
2 TT
3
G
1
14AT
AGND
NC 4
TS 5
2
X45-366X-XX (A/3) [200W]
0-00:TS-480HX (K)
2-71:TS-480HX (E)
AF/SQL VR
X54-3410-00(B/3)
CN7
E40-5409-05
26
-00:TS-480HX (K,E)
-01:TS-480SAT (K,E)
W801(200W)
10
2.0mm Pitch PH
8Pin
1
E37-1059-05
1
14V
14AF
14AG
14S
5V
8C
GND
GND
8
8
12
CN901
E40-6266-05
10
IFIN
GND
8C
TXB
RXB
IFGC
AGC
BLNK
FIL1
FIL2
IFIN
GND
8C
TXB
RXB
IFGC
AGC
BLNK
FIL1
FIL2
CN369
E40-3252-05
14V
14AF
14AG
14S
5V
8C
GND
GND
RXOUT
FMIF
RXB
FILT4
FILT3
FILT2
FILT1
TXIN
FILT5
5C
GND
15.6M
CN555
E40-6273-05
1
CN554
E40-6267-05
1
18
1
14S 6
BOARD
to
BOARD
BOARD
to
BOARD
1.5V
2.MEN1
3.MEN2
4.GND
CN3
E40-5608-05
1
DIN1
GND
BIN
GND
DIN2
5
ATEN
PSC2(ATL5)
IC2+
IC2TH2
TXB
ODP
VDT2
CLK
DATA
FEN1
PSC1
TH1
IC1IC1+
FANL
FANH
GND
CN5
E40-3239-05
SUB UNIT (DRIVE)
X58-4900-XX
CN359
E40-5978-05
CN971
E40-6272-05
1
RXOUT
FMIF
RXB
FILT4
FILT3
FILT2
FILT1
TXIN
FILT5
5C
GND
15.6M
12
CN1
E04-0154-05
DRV
PO
GND
(200W)
CN11
E04-0154-05
(AT) PO
ATOUT
CN819
E04-0154-05
CN4
E40-5607-05
4
DOUT1
GND
GND
DOUT2
1
CN8
E40-3252-05
+B2
+B2
GND
X45-365X-XX (A/3) [AT]
0-11:TS-480SAT (K)
2-71:TS-480SAT (E)
18
3.GND
CN10
1 E40-3246-05
FAN2+
(200W)
FAN22
FINAL UNIT
NC
PSC2
IC2+
IC2TH2
TXB
ODP
VDT2
NC
NC
NC
PSC1
TH1
IC1IC1+
FANL
FANH
GND
(200W)
1.0mm Pitch
18Pin
E37-1069-05
2.TS
M
2
ATEN
ATL5
NC
NC
NC
TXB
NC
NC
CLK
DATA
FEN1
PSC1
TH1
IC1IC1+
FANL
FANH
GND
(AT)
1
CN382
E40-3247-05
CN9
E40-3246-05
FAN1+
FAN1-
CN2
E40-6078-05
1
1.5V
2.NC
3.SQVL
4.AFVL
5.GND
VGS-1
VR2
R31-0644-05
1.TT
1
M
FAN
FAN
GND
GND
W1
E37-1056-05
EXT.AT
CN820
E04-0154-05
ATIN
DC
13.8V
+B1
CN3
E40-5392-05
OPTION
E37-1056-05
+B1
S34
W02-3662-05
MULUT ENC.
/IF SHIFT VR
X54-3410-00(C/3)
PO
(NONE)
(AT-TYPE ONLY)
6
5
4
3
2
1
CN375
E40-5758-05
5C
14S
DATA
CLK
FEN2
GND
AMD
PHD
VSF
VSR
TXB
GND
1
J202
E58-0506-05
1
5C
14S
DATA
CLK
FEN2
GND
AMD
PHD
VSF
VSR
TXB
GND
ATOUT
(200W)
E37-1068-05
CN505
E04-0190-05
J132
E37-1062-05
5C
14S
DATA
CLK
FEN2
GND
GND
GND
VSF
VSR
TXB
GND
ATO
ATI
ANT2
ATIN
GND
(YELLOW)
(AT-TYPE ONLY)
X45-366X-XX (C/3) [200W]
0-00:TS-480HX (K)
2-71:TS-480HX (E)
CN504
E04-0190-05
ANT1
LO1
J131
J1
E37-1061-05
CN503
E04-0190-05
RAT
GND
GND
GND
GND
E37-1063-05
CN2
E04-0154-05
RAT
RAT
PIN
PIN
W101 (200W)
CN102 (AT)
E04-0154-05
GND
GND
GND
GND
POUT
GND
FINAL UNIT (ANT)
E37-1067-05
ANT1
10
E37-1105-05 (200W-TYPE)
E37-1061-05 (BLUE)(AT-TYPE)
IF
CN153
E04-0154-05
CN253
E04-0154-05
X45-365X-XX (C/3) [AT]
0-11:TS-480SAT (K)
2-71:TS-480SAT (E)
GND
ANT2
1
POUT
GND
CN501
E40-5739-05
1
50M
10M
4M
14M
28M
7M
2M
21M
GND
LED
1.0mm Pitch
10Pin
E37-1071-05
10
CN254
E04-0154-05
J731
18
18
JUMPER WIRE
50M
10M
4M
14M
28M
7M
2M
21M
GND
LED
CN101
E40-5734-05
X45-366X-XX (B/3) [200W]
0-00:TS-480HX (K)
2-71:TS-480HX (E)
GND
KEY
DASH
DOT
KYS
AGC
CKYS
PGC
PRES
DATA
CLK
REN
3C
8C
14S
RXB
TXB
GND
SPO
SS
MKE
ALC
COM
RL
BRK
RTK
J302
FINAL UNIT (FILTER)
X45-365X-XX (B/3) [AT]
0-11:TS-480SAT (K)
2-71:TS-480SAT (E)
CN403
1 E40-5978-05
1
3
4
6
2
7
5
8
J301
18Pin
E37-1069-05
1
GND
KEY
DASH
DOT
KYS
AGC
CKYS
PGC
PRES
DATA
CLK
REN
3C
8C
14S
RXB
TXB
GND
2.SPG
NC
KEY
CN309
E40-5978-05
1
3
11
10
2
1
3
11
10
2
GND
GND
GND
DASH
KYS
NC
DOT
1.0mm Pitch
1.SP
2.SPG
E58-0435-05
TX-RX UNIT (TCXO & BPF)
X57-663X-XX (B/2)
0-11:TS-480HX (K)
0-12:TS-480SAT (K)
2-71:TS-480HX (E)
2-72:TS-480SAT (E)
MAIN
ENCODER
CN4
E40-5392-05
1.5V
2.NC
3.SQVL
4.AFVL
5.GND
A
C
D
E
TS-480HX/480SAT
2
F
G
H
I
J
PC BOARD
RF UNIT (X44-327X-XX) 0-00 : KH,KS 2-71 : EH,ES
Component side view (J72-0874-19)
R181
7
C151
20
L152
C155
L154
C124
30
L82
L157
R173
C116
L85
R158
C122
L84
C89
C95
C94
C169
D64
14
R194
C166
RATB R177
R204
C161
L158
C158
D151
L155
3
R172
L151
21
C164
R192
BPF
C78
D60
C120
D65
R193
L79
L83
C91
C171
R178
L156
BC
R61
C152
C154
R153
A1
L162
Q152
43
51
R151
L68
R154
L163
C56
R205
C163
C162
C126
L86
C112
C92
L69
C167
50 D152
C80
C59
C57
L57
L63
C70
L54
D56
C54
PRES
R174
D68
C97
L66
C62
D54
C55
C53
TC52
C130
C129
R16
D5
R176
C165
L56
3C
PRE
10
R155
1
C153
D67
C131
L72
L53
TC51
DT
L81
C118
C68
L71
L65
C74
C76
D59
Q4
C301
28
D63
D61
L51
C24
R20
7
C51
D4
R19
R18
R21
C96
C66
L74
L64
C72
C6
D53
C25
D51
L9
D66
R29
CLK
BPF4
BPF5
EN
8
ATT
IC301
BPF6
L252
BPF2
Q151
C32
DX
+
BPF9
BPF8
10
BPF3
11
12
13
78
14
I
5
NORM
8
C25
A2
BPF7
Ref. No. Address Ref. No. Address Ref. No. Address Ref. No. Address
IC251
8J
D2
6B
D57
5E
D66
4G
IC301
8B
D3
6C
D58
4E
D67
5G
11
CN52
ATT
BC-ATT
9
10
CN51
THRU
BPF10
BPF1
C184
C110
L78
C90
C114
C93
L73
L58
C64
C60
C58
R3
L80
C170
L87
L59
R5
61
Q2
R6
D3
+
C18
+
6
Q302
D2
C12
L62
C23
L7
C15
D57
C19
R12
L75
L11
L6
C8
R11
G
C17
C2
43
1.8
D62
Q3 S
C10
L5
L61
R22
8C
RXB
R10
C4
D
L303
L70
C7
C14
K1
D58
R9
L302
L305
TXB
L60
L2
L4
CN4
ATT
C11
5
L67
D156
L1
4
CN1
DRV
R2
L304
1 GND
KEY
DASH
DOT
KYS
AGC
CKYS
PGC
PRES
DATA
CLK
REN
3C
8C
14S
RXB
TXB
18 GND
CN309
3
CN2
RAT
(BLK)
J72-0874-19
D69
D55
C128
1
B
Q2
Q3
Q4
7A
5D
7C
D4
D5
D51
7C
7C
6D
D59
D60
D61
6E
7G
6G
D68
D69
D151
5G
3G
6H
Q151
Q152
Q251
8I
7I
8O
D53
D54
D55
6E
6D
3E
D62
D63
D64
3G
4G
5G
D152
D156
D253
6H
4H
5O
Q302
6D
D56
7E
D65
7G
D256
6Q
J
K
L
M
N
O
P
Q
R
S
TS-480HX/480SAT
PC BOARD
1
2
3
4
C170
AGC
D253
L164
C198
L166
L167
L168
MCF
R193
L159
CN153
LO1
(BLUE)
L262
CN252
TP2
R184
5
6
L264
R285
C287
A4
R298
IC251
5 4
8
C256
C258
C273
L253
CN152
TP1
MCF
1
C262
G D
S
XF151
Q251
2
C282 R279
R401
R192
52
CN254
IF 10.695MHz
(RED)
D256
R200
R205
R178
C285
A3
R204
C171
L261
R282
L165
R265
C191
B R177
R197 C190
L161
C185
C178
C180
R194
C184
RF UNIT (X44-327X-XX) 0-00 : KH,KS 2-71 : EH,ES
Component side view (J72-0874-19)
PGC
7
CN253
LO2
(WHIT)
L260
R277
CKYS
8
J302
KEY
J301
PADDLE
9
10
Component side
Layer 1
Layer 2
Layer 3
Layer 4
11
Foil side
12
13
79
14
A
C
D
E
TS-480HX/480SAT
2
F
G
H
I
J
L
M
N
O
P
Q
R
C128
R181
7
C151
L152
R173
BPF4
BPF5
ATT
IC301
BPF6
Q152
43
51
BPF9
10
+
11
CN51
THRU
CN52
ATT
L261
R265
D253
R401
IC251
5 4
8
BC-ATT
BPF7
R285
L253
CN152
TP1
MCF
PGC
7
CN253
LO2
(WHIT)
L260
R277
CKYS
8
NORM
C256
BPF10
BPF1
XF151
C273
L252
DX
6
L264
C287
C282 R279
R153
A4
G D
S
C154
Q151
C32
L168
C152
R298
BPF2
L167
Q251
R61
L162
R151
BC
L166
L262
R192
BPF
R154
L68
CN153
LO1
(BLUE)
L159
R193
C164
L163
C56
C198
CN252
TP2
R178
5
D256
R184
L156
R172
L151
C120
21
C78
L83
C91
D65
C80
L57
C59
C57
C171
CN254
IF 10.695MHz
(RED)
A3
MCF
C158
C163
C285
L164
R205
3
L79
R282
R200
L155
D151
C112
C92
L69
L158
C162
C126
C97
L86
50 D152
AGC
L165
R204
C161
A1
BPF8
BPF3
C191
RATB R177
R174
C167
CLK
EN
L161
R197 C190
R194
C166
C185
L157
PRES
C178
C155
L154
L85
R158
C122
L84
C89
C96
C95
C94
C124
14
D68
L63
C70
L54
C54
C53
C130
TC52
TC51
C129
C118
C68
L71
L65
C62
C55
D56
L56
R16
D5
30
C165
L72
L53
3C
PRE
C169
D64
L82
RF UNIT (X44-327X-XX) 0-00 : KH,KS 2-71 : EH,ES
Component side view (J72-0874-19)
R176
C258
20
10
R155
1
4
C153
D67
C131
Q4
C301
DT
L81
D61
L51
C24
R20
7
C51
D4
R19
R18
61
Q2
R21
C116
C66
L74
L64
C72
C74
C76
D53
D59
D54
C18
C25
Q302
+
D51
L9
28
D63
C170
L87
L59
R5
D66
C180
L80
C184
C110
L78
C90
C114
C93
L73
L58
C64
C60
R3
L62
C23
L7
D3
L75
L11
L6
C8
D2
C12
D57
L66
R12
C15
+
6
R6
C58
G
C17
L5
R11
C10
C2
43
3
1.8
D62
Q3 S
R22
L303
L61
C19
L1
8C
RXB
R10
C4
D
C6
C14
K1
D58
L70
C7
R9
L302
L305
TXB
L60
L2
L4
CN4
ATT
C11
5
J72-0874-19
D69
L67
D156
L304
4
CN1
DRV
R2
CN309
1 GND
KEY
DASH
DOT
KYS
AGC
CKYS
PGC
PRES
DATA
CLK
REN
3C
8C
14S
RXB
TXB
18 GND
CN2
RAT
(BLK)
1
C262
J302
KEY
J301
PADDLE
A2
9
9
11
1
2
RF UNIT (X44-327X-XX) 0-00 : KH,KS 2-71 : EH,ES
Component side view (J72-0874-19)
3
10
S
TS-480HX/480SAT
PC BOARD
D55
8
K
PC BOARD
D60
1
B
Ref. No. Address Ref. No. Address Ref. No. Address Ref. No. Address
IC251
8J
D2
6B
D57
5E
D66
4G
IC301
8B
D3
6C
D58
4E
D67
5G
Q2
7A
D4
7C
D59
6E
D68
5G
Q3
5D
D5
7C
D60
7G
D69
3G
Q4
7C
D51
6D
D61
6G
D151
6H
Q151
8I
D53
6E
D62
3G
D152
6H
Q152
7I
D54
6D
D63
4G
D156
4H
Q251
8O
D55
3E
D64
5G
D253
5O
Q302
6D
D56
7E
D65
7G
D256
6Q
10
Component side
Layer 1
Layer 2
Layer 3
Layer 4
11
Foil side
12
12
13
13
14
14
A
1
B
C
D
E
TS-480HX/480SAT
F
G
H
I
J
PC BOARD
2
3
4
S
Ref. No. Address Ref. No. Address Ref. No. Address Ref. No. Address Ref. No. Address
Q1
4Q
Q58
4N
Q158
3L
Q301
7D
D255
6D
Q51
7N
Q59
5N
Q159
7J
D1
4Q
D301
8A
11
12
13
80
14
Q52
Q53
Q54
3O
6O
3O
Q60
Q153
Q154
6N
4K
4L
Q160
Q161
Q252
5J
5I
7E
D52
D154
D155
7P
7I
7H
Q55
Q56
Q57
4N
5N
7O
Q155
Q156
Q157
5L
6J
6I
Q253
Q255
Q256
6E
7B
5C
D251
D252
D254
7L
6F
7D
D302
D303
D304
8C
8D
8B
S
D
Q159
G
L160
R256
R254
R258
C259
R255
C255
C187
C186
C188
R195
C257
C192
R198
C179
R189
R188
C252
R314
9
10
C201
R257
C263
C305
C324
C304
C321
R259
D303
C325
D301
C322
R313
R179
C176
C177
C261
C269 R266
D302
D304
C323
8
L265
D154
MCF
R185
C174
R297
R199
C194
C193
C266
C297 R263 R260
L256
D155
G
S
Q156
LO1
R196
C277
R271
R270
C295
R264
R276
Q301
C195
R206
C281
R281
C274
L259
R315
R293
R286
R284 R292
C290
C288
R283
C276
D254
C196
C303
C286
D252
Q252
LO2
R280
R296
MCF
GND
L263
7
L255
C271
Q255
C292
R289
C293
R287
C291
R288
R182
D
Q157
GND
D255
D
G
Q253
6
Q160
D
G
S
R183
C182
S G1
R186
R262
L254
R269
C272
C268
C270
D G2
L258
R187
Q161
S
G
D
C267
C260
R275
R268
C280
R290
R295
C298
Q256
R291
TH251
R294
L257
GND
R278
IF
C278
5
C275 C279
RF UNIT (X44-327X-XX) 0-00 : KH,KS 2-71 : EH,ES
Foil side view (J72-0874-19)
J
K
L
M
N
O
P
Q
R
S
TS-480HX/480SAT
PC BOARD
2
RF UNIT (X44-327X-XX) 0-00 : KH,KS 2-71 : EH,ES
Foil side view (J72-0874-19)
R191
Q158
R72
R190
R52
C33
Q54
7M
L10
R4
DRV
4
D1
R58
R7
C3
10M
C67
C83
C102
R79
R66
21M
C73
Q55 Q58
C123
C117
C86
R164
S G1
C105
R163
D G2
Q154
R162
S G1
C157
R161
D G2
Q153
R65
C5
RAT
L3
L153
R76
R165
R1
R54
Q1
C65
GND
R63
C82
C101
C156
R157
R159
R156
C115
R73
R202
Q52
R62
C61
C99
C173
R152
3
1.8M
6 1
C111
4 3
C79
J72-0874-19
1
R55
R8
GND
C13
C16
L301
R14
R17
C75
Q59
Q56
C69
Q57
R57
C30
7
D52
R15
BC
C20
R51
R317
R316
C254
CP302
8
CP303
GND
C302
C71
21M
R301
R71
C28
C1
R53
C29
L52
C26
L55
C77
Q60
6
14S
C52
3.5M
R82
C98
C22
R60
Q51
R64
C108
R81
C109
L77
5
L251
R251
R253
C252
C85
C181
C255
C187
D251
C253
R56
Q53
C63
C81
C113
C100
R70
GND
6
R254
C104
C121
D
C88
R69
R75
C176
R255
14M
50M
R78
BPF
L160
R67
R13
R59
R77
C174
8
C84
C103
C119
C200
R185
R179
C87
C125
C106
R74
C127
S
Q156
R68
C107
G
R170
C159
2
C168
D
R168
Q155
R160
R175
R186
Q160
D
G
S
30M
R80
R167
9
10
Component side
Layer 1
Layer 2
Layer 3
Layer 4
11
Foil side
12
13
81
14
A
C
D
E
TS-480HX/480SAT
F
G
H
I
J
K
L
M
N
PC BOARD
O
2
Q
R
S
TS-480HX/480SAT
RF UNIT (X44-327X-XX) 0-00 : KH,KS 2-71 : EH,ES
Foil side view (J72-0874-19)
R191
Q158
R72
R190
C33
Q54
C5
R4
L3
DRV
4
D1
R58
R7
C3
10M
C67
C83
C102
21M
C73
Q55 Q58
C123
C117
C86
R164
S G1
C105
R163
D G2
Q154
R162
C157
S G1
Q153
R1
Q1
C82
C65
C115
C156
L10
RAT
R55
R8
C13
C16
L301
R14
Q57
21M
R57
7
D52
R15
BC
C20
R316
CP302
11
CP303
R317
C302
GND
R301
R51
8
9
9
10
C30
C28
C1
R53
C29
L52
C26
L55
C77
Q60
6
14S
C52
3.5M
Q53
C63
R60
R82
C108
R71
C71
R64
C98
R81
C109
C22
L251
L77
5
C254
C252
C85
C181
C187
R251
R253
C253
R56
R17
C75
Q59
Q56
C69
C87
C81
R70
GND
D251
R254
C257
C113
C100
R179
C255
R256
C260
C259
R255
C261
R258
C88
C127
C107
R69
R75
L160
14M
50M
R78
C186
C188
R195
R67
R13
R59
R77
C121
S
D
Q159
G
R198
C179
R189
R188
C84
C103
C119
Q155
R74
C200
R175
R68
C104
C201
C192
C125
C106
R170
C159
R168
C176
C177
30M
R80
R167
BPF
R257
R314
C263
C305
C324
C304
C321
C322
R259
D303
C325
D301
C323
R313
R66
R185
R196
C269 R266
D302
D304
R65
R79
C174
D154
C193
MCF
L265
G
S
Q156
LO1
R297
R199
C194
D155
C266
C297 R263 R260
L256
R271
R270
C295
C277
R264
Q301
R276
L259
R315
R293
R286
C288
C290
R296
R283
C274
C195
C303
R284 R292
R280
C276
D254
C196
R206
C281
R281
LO2
C286
D252
Q252
L263
7
MCF
GND
R182
D
Q157
L255
C271
Q255
C292
C293
R287
R289
C291
R288
D
G
GND
D255
7M
R54
L153
R160
C168
S
Q253
6
Q160
D
G
S
R183
C182
S G1
R186
R262
L254
R269
C272
C268
C270
R187
Q161
S
G
D
D G2
L258
GND
R63
2
GND
C267
R268
R278
C280
R290
R295
C298
Q256
R291
TH251
R294
L257
GND
R275
C278
IF
C275 C279
5
R161
R165
RF UNIT (X44-327X-XX) 0-00 : KH,KS 2-71 : EH,ES
Foil side view (J72-0874-19)
R202
R52
R76
D G2
4
R157
R159
R156
C101
R73
R152
Q52
C173
R62
C79
6 1
1
3
1.8M
C99
4 3
C111
3
C61
J72-0874-19
8
P
PC BOARD
Q51
1
B
Ref. No. Address Ref. No. Address Ref. No. Address Ref. No. Address Ref. No. Address
Q1
4Q
Q58
4N
Q158
3L
Q301
7D
D255
6D
Q51
7N
Q59
5N
Q159
7J
D1
4Q
D301
8A
Q52
3O
Q60
6N
Q160
5J
D52
7P
D302
8C
Q53
6O
Q153
4K
Q161
5I
D154
7I
D303
8D
Q54
3O
Q154
4L
Q252
7E
D155
7H
D304
8B
Q55
4N
Q155
5L
Q253
6E
D251
7L
Q56
5N
Q156
6J
Q255
7B
D252
6F
Q57
7O
Q157
6I
Q256
5C
D254
7D
10
Component side
Layer 1
Layer 2
Layer 3
Layer 4
11
Foil side
12
12
13
13
14
14
A
B
C
TS-480HX/480SAT
D
E
SCHEMATIC DIAGRAM
RF UNIT (X44-327X-XX)
1
14S
13.11V
13.19V
Q2
HN7G01FU
10k
RATB
R10
RXB
ATT
SWITCHING
47p
56
R19
100
L9
1u
D51
HVC131
C55
L54
1500p
5.6u
* L53
* L51
C20
0.01u
C51
1500p
56
*
C54
2200p
C53
2200p
R:0V
T:0.67V
* C130
C129
D1
MA2S111
C5
0.01u
1000u
R:13.17V
T:0V
MUTE
Q4
R4
1000u
SWITCHING
SURGE ABSORPTION
K1
S51-1428-05
L55
C52
HVC131
SWITCHING
D54
L52
0.1u
D4
D5
3
-114dBm
LIMITER
V08(G)
47p
C12
8p
C8
0.1u
D2-5
0.01u
C29
0.1u
-114dBm
1000u
C26
150n
C11
C24
470
C18
HVC131
0.01u
C15
2.2k
L6
R16
R7
R15
V08(G)
RLS245
RAT(B)
CN2
E04-0154-05
RAT
RLS245
1000p
D2
D3
D52
C16
L5
10u
0.1u
R8
180
C13
-115dBm
FINAL UNIT(ANT)
X45-365X-XX(C/3)[AT]
X45-366X-XX(C/3)[200W]
CN503
0V
2SD1757K
* TC51
0.13V
7.68V
SWITCHING
* TC52
CN4
E40-5487-05
C30
RX POWER SUPPLY
CONTROL SWITCH
DX
E18-0254-05
1000p
C28
R18
Q302
KRC402E
0.17V
2
0.1u
47k
SWITCHING
12.37V
CN51
E40-5487-05
7.64V
1k
R6
C1
1000p
C2
C32
NORM
470u16
R5
14S
56
CN52
E40-5487-05
470u16
E18-0254-05
4.7k
R21
R20
C3
0.01u
Q1
KRA318E
4.7k
L1
10u
L11
100n
C23
R22
0
L7
1000u
C25
4.7u25
C22
0.01u
10
0.1u
R9
10k
C17
0.1u
33k
0.1u
R13
C10
R17
L4
C7
150
R12
680
C4
R3
39p
R14
R301
BPF2
BPF8
BPF9
BPF10
BPF7
2.47V
3C
ATT
0.16V
PRE
3.33V
4.7k
PRE
CP303
RK75GB1J103J
H:ATT ON
H:PRE ON
ATT
R82
Q301
KRC402E
SWITCHING
R317
R316
0V
CP302
RK75GB1J103J
10k
10k
2.92V
0.1u
C302
47k
100
R315
1000p
C325
1000p
C305
R314
R:0.05V
T:1.71V
L3
14S
D301-304
D53
LFB01
SWITCHING
TXB
CN309
E40-5978-05
6
AGC
7
CKYS
PGC
PRES
DATA
8
PGC
9
PRES
10
DATA
CLK
REN
11
CLK
3C
8C
14S
13
L301
1u
14
L302
1u
8C
8C
15
L303
1u
14S
PRE
RXB
TXB
16
L304
1u
RXB
RXB
17
L305
1u
TXB
TXB
GND
18
12
REN
Q5
Q6
Q4
10
Q3
9
8
Q2
SHIFT
REGISTER
Q1
7
Q0
LCK
6
5
4
CLK
DATA
3
2
NC
VSS
Q7
Q8
Q9
Q10
Q11
SO
19
OE
VDD
0.01u
C301
IC301
BU2099FV
11
KYS
AGC
CKYS
12
DOT
5
13
DASH
4
14
3
15
DASH
DOT
KYS
16
KEY
17
2
18
1
20
GND
KEY
1
TX-RX UNIT
X57-663X-XX(A/2)
CN403
820
R1
1000p
1SS388
C19
0.1u
Q3
2SK2596
AMP
14S
15p
R11
330
R:0V
T:0.57V
1000p
C323
D303
C324
1SS388
REVERSE
CURRENT
PREVENTION
6
820
1000p
C322
1000p
D302
1000p
C304
KEY
2
10
11
3
1
E11-0455-05
C14
0.01u
1SS388
0
5
C6
1u
47u
DASH
KEY
J302
L2
100n
6.8
1SS388
1000p
47k
R313
C321
D301
C303
PADDLE
J301
E11-0455-05
D304
DOT
2
10
11
3
1
R:13.18V
T:12.51V
R2
KYS
270n
L10
C33
FINAL UNIT
X45-365X-XX(A/3)[AT]
X45-366X-XX(A/3)[200W]
CN1
18p
4
DRV(B)
ATT
8C
47u
7.59V
CN1
E04-0154-05
DRV
BPF1
BPF3
BPF6
BPF5
BPF4
3C
AGC
GND TP for JIG
CKYS
PGC
PRE GAIN
7
82
X44-327 1/4
F
G
H
I
TS-480HX/480SAT
SCHEMATIC DIAGRAM
RF UNIT (X44-327X-XX)
J
RATB
RATB
RXB
R81
56
2200p
SWITCHING
21M
14.5~21.5M
SWITCHING
220p
0.1u
28M
21.5~30M
SWITCHING
C124
56p
0.1u
30~49M
54~60M
SWITCHING
180p
C126
L86
0.1u
C127
C107
47
1000p
50M
49~54M
33
R77
120p
L66
C88
0.1u
R69
1000p
C76
C77
L87
270n
15p
14M
10.5~14.5M
47
0V
C131
13.00V
BPF10
SWITCHING
D68
HSC277
C97
Q60
KRA318E
R60
C125
L85
C106
33
150n
R68
10M
7.5~10.5M
D67
HSC277
1000p
68p
47
56p
L65
150n
270n
82p
13.02V
SWITCHING
1SV312
C95
47
R59
0V
C87
C75
BPF9
0.1u
C74
D59
13.00V
1000p
Q59
KRA318E
13.02V
L75
R80
47
R58
SWITCHING
C128
1200p
0.1u
1800p
0.1u
820p
0.1u
680p
0.1u
470p
0.1u
330p
C122
47
C123
L84
33
180n
56p
R65
SWITCHING
D66
HSC277
C89
SWITCHING
SWITCHING
1u
0.01u
1000u
2.2u
C110
C112
C113
1.5u
1u
C114
C115
0.1u
C104
33
C111
L78
68p
R64
1000p
C99
1.2u
7M
4.1~7.5M
D65
HSC277
L83
C91
1000p
L79
47
L72
SWITCHING
D64
HSC277
C103
33
R76
180n
220p
L64
C86
0V
0.1u
BPF8
1000p
C72
C73
13.00V
C100
100p
R67
1000p
L80
1.8u
L70
Q58
KRA318E
C101
C94
L82
L71
680n
13.02V
C102
47
R79
33
C116
150p
R66
C118
2.2u
3.5M
2.5~4.1M
D63
HSC277
L81
C96
C119
47
R73
L74
C105
330p
L63
C85
33
C120
330p
C121
2.7u
SWITCHING
D62
HSC277
470n
C93
1000p
C117
L73
390n
47
R78
33
1000p
R70
1.8M
1.705~2.5M
D61
HSC277
270n
470p
1000p
47
5.6u
1000p
1SV312
47
R57
0V
SWITCHING
C71
BPF7
0.1u
C70
D58
13.00V
1000p
Q57
KRA318E
270n
SWITCHING
13.02V
C92
R74
470p
L62
390n
47
1.96V
C84
BPF6
0.1u
C69
2.64V
1000p
C68
Q56
KRA318E
0.13V
R56
680p
L61
1SV312
47
R55
0V
C83
C67
BPF5
0.1u
C66
D57
13.00V
1000p
Q55
KRA318E
470n
SWITCHING
SWITCHING
R72
2.2u
1200p
L58
C79
L59
1800p
0.1u
1000p
C81
L60
47
R54
0V
L69
47
BPF4
13.02V
BC
30K~1.705M
D69
HSC277
33
R63
C82
C65
13.00V
0.1u
C64
Q54
KRA318E
13.02V
820p
1SV312
47
R53
0V
SWITCHING
R62
1u
C63
BPF3
1000p
D56
C62
13.00V
1.5u
SWITCHING
13.02V
SWITCHING
C90
1200p
R75
Q53
KRA318E
SWITCHING
L67
6.8u
47
R52
0V
SWITCHING
0.1u
C61
BPF2
1000p
C60
RN731V
SWITCHING
C58
13.00V
2200p
D55
Q52
KRA318E
13.02V
D60
HVC131
SWITCHING
47
R51
0V
SWITCHING
L77
R71
BPF1
47
C80
C59
470
2200p
6.8u
2200p
C57
R61
C98
6.8u
C108
L57
2200p
C56
13.00V
2200p
Q51
KRA318E
13.02V
SWITCHING
1000u
220p
L56
C109
L68
0.1u
RXB
C78
8C
8C
PRE
PRE
RXB
RXB
TXB
TXB
AGC
AGC
CKYS
CKYS
PGC
PRE GAIN
PGC
PRE GAIN
83
X44-327 2/4
K
L
M
TS-480HX/480SAT
N
O
SCHEMATIC DIAGRAM
RF UNIT (X44-327X-XX)
RATB
RATB
SWITCHING
1.97V
R184
270
R179
1000p
10u
0.01u
0.1u
C184
C201
1000p
1k
470p
C178
0.01u
0.01u
C181
C167
0.1u
10
R173
C177
470
1.76V
RX LO1
R189
680
R193
10k
1000p
0V
1k
R195
33k
C186
0.01u
22
R185
0
R170
1000p
C174
0.70V
47
R168
47
R167
0.1u
C157
R188
RATB
100u
C179
PRE AMP
Q154
3SK131(M)
C159
68k
47k
R165
47k
R159
L163
470n
LO1 AMP
0.1u
R157
L160
12.25V
Q159
2SK2596
R164
10
100k
4.30V
C176
2.44V
R163
10
R156
Q160,161
RX 1st
MIXER
R192
4.51V
0.1u
5p
C156
2.44V
Q161
2SK520(K44)
1000p
R162
10
220
R152
10
10
L159
L39-1480-05
8.3dBm
L157
L39-1476-05
C166
330n
0.1u
220
R202
C151
0.01u
R161
L153
C153
L152
L39-1476-05
D156
HSC277
Q153
3SK131(M)
10
R197
Q157
3.3u
4.51V
10
2SK520(K44)
PRE AMP
-113dBm
SWITCHING
470
R174
L154
R158
1.8k
R187
2p
C185
RX 73.095M
0.1u
R178
12.01V
C155
R194
2.2k
R205
-96dBm
R183
-101dBm
1000p
R204
2.2k
0.1u
560
C171
L164
L34-4709-05
12.30V
12.30V
680
0.01u
10
12
SWITCHING
C168
39p
R175
15p
C165
100n
C163
33p
150n
C161
C162
L156
56p
C158
SWITCHING
L155
82p
D152
1SV312
D151
HSC277
R186
10
0.1u
100u
C180
R182
C170
-101.5dBm
2.47V
Q160
2SK520(K44)
L161
680
0.01u
C182
0.01u
C164
R172
L158
L39-1476-05
1st MIXER
Q156
2SK520(K44)
R177
5.6k
C154
0.1u
C152
L151
1000u
PRE
1000p
0.02V
R206
R155
6.8k
R153
120
R154
120
10k
Q151
KRC402E
Q156,157
RX 1st
MIXER
4.30V
330
C190
L165
0V
BPF WAVE-FORM
R151
SWITCHING
RXB
Q152
RN47A5
12.63V
C191
RXB
L162
RXB
470p
0.1u
C188
C187
Q158
HN7G01FU
SWITCHING
R181
11.94V
2.46V
0.1u
C173
1k
12.72V
R191
1k
PRE
RATB
R190
10k
12.68V
0.01u
C200
47k
KRC418E
470
0.1u
C169
R160
PRE GAIN
R176
47u
Q155
0V
SWITCHING
0.25V
TX LO1
R297
VCC
Lo2
Lo1
1
C259
470
470p
L265
470n
L253
L39-1480-05
C262
1k
0.01u
C260
R256
R:0V
T:2.59V
R255
0.01u
R258
R:0.16V
T:4.03V
0.1u
C256
C255
82
100
47
R254
R:0V
T:2.59V
100u
R253
L251
R251
0.1u
0.01u
C253
8
C252
R257
2
330
GND
3
R259
RF2
7
0.01u
RF1
IF2
C261
680
R298
IF1
6
4p
4
5
47
C258
0.01u
0.01u
L39-1476-05
R:0V
T:2.15V
C257
D251
HSC277
R:0V
T:2.15V
IC251
TA4107F
R:0.16V
T:4.02V
1k
L252
0
TX MIXER
R:0.16V
T:4.02V
SWITCHING
0.01u
TXB
C263
0.1u
C254
TXB
8C
TX 73.095M
8C
PRE
RXB
RXB
TXB
AGC
AGC
CKYS
CKYS
PGC
PRE GAIN
84
X44-327 3/4
PGC
PRE GAIN
P
Q
R
S
TS-480HX/480SAT
SCHEMATIC DIAGRAM
RF UNIT (X44-327X-XX)
T
1
MCF(B)
CN152
E40-0211-05
1
2
SWITCHING
D155
DAN235E
2p
C193
TP1
MCF WAVE-FORM
ALIGNMENT
73.095M MCF
L166
L34-4408-05
L168
L34-4408-05
-101dBm
1p
C195
XF151
L71-0605-05
RX 73.095M
1000p
R200
330
C198
3p
C196
330
R199
1000p
C194
2
L167
L34-4408-05
SWITCHING
LO1(B)
D154
DAN235E
CN153
E04-0154-05
LO1
C192
R196
0.01u
1k
R198
0
TX-RX UNIT
X57-663X-XX(A/2)
CN3
TP2
MCF(B)
3
MCF WAVE-FORM
ALIGNMENT
CN252
E40-0211-05 1
R282
2
330
REVERSE
CURRENT
PREVENTION
10
R275
AGC(A)
1p
C281
0.01u
47u
C285
L261
1000p
470n
C279
L257
C275
6p
MA2S111
D253
R265
470k
330
R262
RX LO1
C280
470n
L258
10k
R268
0.1u
C272
1000p
C267
47u
L254
1000p
10.695MHz
IF(B)
7.57V
SWITCHING
L262
L39-1480-05
RX IF AMP
100
R294
R290
CN501
0.01u
C293
R285
330
C287
0.01u
0
R281
330
C278
2.10V
TX-RX UNIT
X57-663X-XX(A/2)
100
3.9k
SWITCHING
CN254
E04-0191-05
IF
-t
22p
C292
TH251
1.47V
1000p
C270
1000p
R269
DAN235E
1p
C268
390n
4
-91dBm
R291
L264
L39-1480-05
D256
HSB88WS
Q253
3SK317
L255
R278
D252
RX 2nd/TX MIXER
47
2.75V
-85dBm
220
D255
DAN235E
TX LO1
C282
47u
5
0.01u
L260
1000p
C273
R279
330
3.3k
33p
R270
10
R266
100n
C297
1000p
L256
C269
0
R260
TX 73.095M
+6.1dBm
R:0.18V
T:6.90V
0V
R263
C290
0V
C291
R288
9p
0.01u
470
C298
R287
18
0
330
R295
Q255
2SC3356
R292
0.64V
0.01u
10k
C277
0.01u
470n
L263
120k
7.64V
LO2 AMP
R277
Q256
KRC418E
SWITCHING
R289
R276
1.8k
47
PGC
Q251
2SK1830
6
1000p
R286
22
C288
22
R296
0.01u
C286
R:0V
T:2.95V
33
R293
C295
0.1u
0.01u
0.39V
C274
TXB
RN731V
R280
1000p
C271
47
R264
R271
1000p
R:0V
T:0.47V
SWITCHING
D254
470
R:0V
T:1.57V
R284
ATTENUATOR
C276
1000p
330
R:0.07V
T:2.31V
Q252
2SC3356
10
330
C266
R283
TX IF AMP
LO2(B)
CN253
E04-0154-05
LO2
8C
TX-RX UNIT
X57-663X-XX(A/2)
CN1
RXB
AGC
CKYS
TC51
TC52
L51
L53
C129
C130
0-00
TS-480HX/480SAT
X44-327X-XX
K
NO
NO
NO
NO
NO
NO
2-71
TS-480HX/480SAT
E
C05-0385-05
C05-0385-05
6.8u
6.8u
9p
9p
PGC
PRE GAIN
7
85
X44-327 4/4
RF UNIT (X44-327X-XX)
14S
Q2
HN7G01FU
RX 73.095M
1000p
1p
R282
330
10
R275
L258
1p
C281
470n
10k
R268
C272
0.1u
1000p
22p
220
R294
R290
0.01u
C293
R285
330
C287
0.01u
0
R281
47
C292
C282
0.01u
C273
3.3k
R270
33p
100n
C297
1000p
10
R266
1000p
L256
C269
4p
C261
0
R260
0V
C290
R288
9p
0.01u
470
C298
330
330
R295
18
0
R289
0.64V
0V
C291
Q255
2SC3356
R292
1000p
C288
R286
22
22
R296
C286
0.01u
C295
0.01u
C274
0.39V
LO2(B)
CN253
E04-0154-05
LO2
8C
RXB
RXB
AGC
AGC
AGC
AGC
AGC
CKYS
CKYS
CKYS
CKYS
CKYS
PGC
PGC
PGC
PGC
PGC
PGC
PRE GAIN
470n
7.64V
LO2 AMP
R:0V
T:2.95V
8C
L263
47
Q256
KRC418E
SWITCHING
R287
R271
C271
47
R264
0.01u
C263
TXB
RN731V
R280
PGC
Q251
2SK1830
TXB
D254
R284
ATTENUATOR
1000p
R:0V
T:0.47V
SWITCHING
330
R259
0.01u
C260
R:0V
T:1.57V
0.01u
R:0.07V
T:2.31V
Q252
2SC3356
120k
330
C266
1k
R256
C257
330
C278
R191
1k
1000p
R278
3.9k
1p
C268
R269
470p
0.1u
0.01u
TX IF AMP
C276
0.01u
1k
R255
0.1u
C255
82
47
0.01u
47u
C285
L261
1000p
470n
C279
L257
C275
6p
MA2S111
D253
R265
470k
R262
330
C267
47u
L254
R195
1k
0.1u
C188
C187
L265
470n
0
R:0V
T:2.59V
100u
0.1u
+6.1dBm
R:0.18V
T:6.90V
R263
AGC
PRE GAIN
1000p
R200
1k
R198
0.01u
33k
10k
R193
C186
0.01u
C174
R257
470p
CKYS
PRE GAIN
330
C198
3p
C196
330
R199
1000p
C194
R206
1k
C201
470p
2p
C185
C178
0.01u
C182
C181
R189
680
R190
10k
0.01u
C200
47k
C259
470
C262
0.01u
R258
R:0.16V
T:4.03V
TXB
C254
C127
2p
C193
C195
1000p
0.01u
10
0.1u
C184
L161
100u
C180
R194
R197
R184
270
12
10
R173
10u
L165
R205
2.2k
R179
C167
0.1u
R174
470
0.1u
C166
0
R170
47
R168
47
R167
0.1u
1000p
R204
2.2k
0.1u
560
C168
R175
C165
C162
82p
56p
68k
C157
47k
R165
R192
C164
R172
0.1u
C154
47k
R159
330
C190
R155
6.8k
C152
1000p
5p
100k
R157
680
C256
100
R253
0.1u
L251
C126
180p
L86
C107
47
1000p
50M
49~54M
R77
1000p
120p
L66
C88
0.1u
R251
C106
47
R80
C75
C76
L87
270n
15p
SWITCHING
0.1u
R59
47
C131
Q4
Q3
9
10
Q2
8
Q1
7
6
Q0
LCK
CLK
5
4
1
1000p
47
R60
C77
Q5
Q6
Q7
Q8
Q9
Q10
Q11
SO
Lo1
R:0V
T:2.59V
L253
L39-1480-05
33
18
DATA
Lo2
2
47u
R293
GND
3
VCC
L260
10
TXB
19
RF2
GND
R279
330
R283
RXB
TXB
OE
IF2
CN501
TX LO1
470
RXB
TXB
NC
3
TX-RX UNIT
X57-663X-XX(A/2)
-t
100
TX 73.095M
0.01u
RXB
TXB
TX 73.095M
47
C258
0.01u
CN254
E04-0191-05
IF
0.25V
R276
RXB
TXB
2
2.10V
100
TH251
1.47V
SWITCHING
11.94V
2.46V
RF1
6
C270
1000p
10k
RXB
1u
VDD
DAN235E
C277
1u
L305
VSS
390n
-91dBm
R291
L264
L39-1480-05
D256
HSB88WS
Q253
3SK317
L255
12.72V
R277
L304
17
0.01u
Q158
HN7G01FU
D252
RATB
RX 2nd/TX MIXER
L262
L39-1480-05
RX IF AMP
1.8k
16
1
2.75V
-85dBm
1000p
RXB
TXB
PRE GAIN
IF(B)
D255
DAN235E
0.1u
PRE
C301
R154
C173
PRE
PRE GAIN
10.695MHz
L162
R:0V
T:2.15V
4
5
R298
PRE
GND TP for JIG
120
R153
PRE
0.01u
C253
C252
14S
0V
R69
C280
1000p
30~49M
54~60M
R254
C124
1u
C125
L303
0.1u
15
1000p
8C
1000p
8C
C87
8C
BPF10
SWITCHING
0.1u
8C
11
8C
12
1u
13
L302
14
14
15
3C
REN
16
1u
17
L301
12
18
13
20
3C
8C
14S
82p
2
SWITCHING
R:0V
T:2.15V
8
CLK
REN
BPF1
BPF3
BPF6
BPF5
BPF4
L39-1476-05
TP2
RX LO1
D68
HSC277
C97
33
TX MIXER
IC251
TA4107F
R:0.16V
T:4.02V
SWITCHING
PGC
33
RX LO1
1000p
12.68V
7
CKYS
R68
REVERSE
CURRENT
PREVENTION
SWITCHING
R:0.16V
T:4.02V
L252
28M
21.5~30M
8
CLK
120
C156
R156
D251
HSC277
7
DATA
220
R202
SWITCHING
D66
HSC277
TX-RX UNIT
X57-663X-XX(A/2)
CN3
MCF WAVE-FORM
ALIGNMENT
CN252
E40-0211-05 1
AGC(A)
R181
SWITCHING
56p
68p
L85
C95
0
TX LO1
D67
HSC277
150n
L75
270n
0.01u
RATB
SWITCHING
220p
C122
C123
0.1u
180n
L84
C105
47
R76
33
1000p
R65
R196
7.57V
Q155
IF1
56p
CN153
E04-0154-05
LO1
C192
1.76V
21M
14.5~21.5M
PGC
PRES
DATA
11
0.01u
1k
KYS
10
470
PRE
AGC
PRES
220
C114
C116
C118
470p
0.1u
C119
SWITCHING
330p
0.1u
C121
C104
1000p
47
C89
LO1(B)
D154
DAN235E
0.70V
KRC418E
470
6
9
C177
R297
33
-101dBm
L167
L34-4408-05
SWITCHING
100u
C179
PRE AMP
Q154
3SK131(M)
C159
R160
PRE GAIN
14M
10.5~14.5M
5
13.00V
LO1 AMP
R188
Q159
2SK2596
R164
10
L163
470n
12.25V
D65
HSC277
C120
68p
R64
390n
L82
1.2u
1000p
C103
C91
L83
L72
L160
C176
2.44V
R163
10
L168
L34-4408-05
XF151
L71-0605-05
47u
AGC
CKYS
Q60
KRA318E
1.97V
4.51V
4.30V
RXB
DOT
13.02V
R152
C151
0.1u
C115
820p
SWITCHING
4
1SV312
2.44V
73.095M MCF
L166
L34-4408-05
MCF(B)
1000p
R162
10
2
MCF WAVE-FORM
ALIGNMENT
L159
L39-1480-05
8.3dBm
L157
L39-1476-05
10
Q160,161
RX 1st
MIXER
0V
KEY
0V
Q153
3SK131(M)
Q161
2SK520(K44)
2SK520(K44)
0.1u
DASH
SWITCHING
330n
0.1u
10M
7.5~10.5M
3
SHIFT
REGISTER
R161
L153
C153
L152
L39-1476-05
7M
4.1~7.5M
2
IC301
BU2099FV
4.51V
SWITCHING
SWITCHING
L154
10
10
Q157
D64
HSC277
270n
47
R74
33
RX 73.095M
R187
R183
0.1u
R178
PRE AMP
0V
R67
C171
-101dBm
L164
L34-4709-05
12.30V
-96dBm
3.3u
1.8k
-113dBm
DASH
DOT
KYS
BPF9
C158
C128
2200p
1800p
C112
C113
0.1u
SWITCHING
1
13.00V
39p
10
12.30V
R176
100p
100n
C163
C169
1.8u
150n
C161
R158
C155
R186
R182
0.1u
C94
L156
12.01V
3.5M
2.5~4.1M
Q160
2SK520(K44)
C170
680
D156
HSC277
0.1u
C102
L71
1000p
C117
47
R79
33
680
SWITCHING
680p
R66
1st MIXER
Q156
2SK520(K44)
10
L155
15p
D63
HSC277
L81
C96
150p
1u
L80
C101
47
L74
2.2u
1000p
33
R75
1000p
1000p
1000p
SWITCHING
GND
KEY
13.02V
L151
1u
C98
C108
0.01u
1200p
C110
C111
0.1u
L78
2.2u
1000p
C99
L79
C100
1000p
47
330p
R73
1000p
1000p
C83
0.1u
56p
L65
D59
D152
1SV312
D151
HSC277
1.8M
1.705~2.5M
D62
HSC277
C93
1u
820p
L60
C82
680p
L61
470n
390n
470p
L62
C84
0.1u
330p
L63
C85
0.1u
270n
180n
220p
L64
C86
C72
C73
47
R58
SWITCHING
Q59
KRA318E
2.47V
0.01u
33
R78
1000p
R70
L158
L39-1476-05
D61
HSC277
1.5u
47
R72
L58
1200p
C60
2.2u
1000p
C79
0.1u
1800p
1.5u
L59
C81
0.1u
C92
470p
4.30V
R177
0.1u
SWITCHING
SWITCHING
150n
PRE
2200p
C63
C64
C66
C71
47
R57
13.00V
13.02V
BPF2
BPF8
BPF9
BPF10
BPF7
ATT
L69
5.6u
Q156,157
RX 1st
MIXER
-101.5dBm
D69
HSC277
33
680n
Q58
KRA318E
0.1u
CP303
RK75GB1J103J
R317
R316
CP302
RK75GB1J103J
10k
10k
0.1u
R62
L70
0V
2.47V
3C
1SV312
BPF8
0.16V
4.7k
R82
3.33V
C67
C68
D58
13.00V
SWITCHING
H:ATT ON
H:PRE ON
PRE
R71
47
47
47
47
Q57
KRA318E
BPF7
C302
47k
R315
R56
C25
4.7u25
C22
0.01u
10k
0.1u
R13
C17
SWITCHING
0V
ATT
C69
R22
0
R17
150
R12
10
C10
0.1u
R9
1.96V
SWITCHING
33k
R301
0V
CN309
E40-5978-05
2.64V
BPF6
100
SWITCHING
R55
1000u
L7
47u
L4
Q56
KRA318E
13.02V
2.92V
Q301
KRC402E
1SV312
SWITCHING
R14
0.1u
C7
SWITCHING
D53
LFB01
R:0.05V
T:1.71V
680
C4
39p
R3
820
R1
1000p
1000p
C325
1000p
C305
0
BPF5
TXB
14S
R314
C19
0.1u
L3
14S
1SS388
D301-304
13.00V
0.13V
R:0V
T:0.57V
1000p
C324
D303
REVERSE
CURRENT
PREVENTION
TX-RX UNIT
X57-663X-XX(A/2)
CN403
820
1000p
C322
1000p
KEY
330
AMP
1SS388
1000p
C304
D302
D57
0V
Q3
2SK2596
0.02V
PRE
15p
R11
0.01u
1u
47u
2
10
11
3
1
E11-0455-05
C14
1SS388
C323
C303
D301
R54
4.7k
R21
R20
4.7k
0.01u
C3
DOT
DASH
KEY
J302
C6
100n
6.8
1SS388
1000p
47k
C321
R313
270n
L10
C33
J301
E11-0455-05
D304
KYS
2
10
11
3
1
PADDLE
L2
R2
18p
FINAL UNIT
X45-365X-XX(A/3)[AT]
X45-366X-XX(A/3)[200W]
CN1
1200p
R63
SWITCHING
Q55
KRA318E
13.02V
R:13.18V
T:12.51V
0.1u
* TC52
0V
L11
100n
DRV(B)
ATT
8C
C65
C54
47
13.00V
BPF4
C23
7.59V
CN1
E04-0154-05
DRV
6.8u
2.7u
13.02V
SWITCHING
Q1
KRA318E
1SV312
Q54
KRA318E
L1
10u
C90
L73
2200p
C53
*
2200p
C130
*
* TC51
0.13V
SWITCHING
R53
L54
5.6u
* L53
0V
SWITCHING
C74
56
C129
R:0V
T:0.67V
D56
BPF3
2SD1757K
7.68V
13.00V
13.02V
1500p
C62
C55
SWITCHING
C70
1u
0.01u
C29
* L51
D5
C51
1500p
L67
47
SWITCHING
R52
HVC131
0.1u
C52
0V
Q53
KRA318E
MUTE
C61
1000u
R:13.17V
T:0V
MA2S111
D1
0.01u
C5
1000u
BPF2
LIMITER
Q4
R4
L55
SWITCHING
SURGE ABSORPTION
K1
S51-1428-05
SWITCHING
D54
L52
13.00V
13.02V
RN731V
SWITCHING
C58
56
L9
1000u
C26
R15
R19
V08(G)
100
D51
0.01u
C12
47p
47p
-114dBm
HVC131
C24
D2-5
8p
D55
-114dBm
Q151
KRC402E
SWITCHING
HVC131
0.01u
0.1u
2.2k
0.1u
C20
150n
C11
R16
D3
470
SWITCHING
Q52
KRA318E
RLS245
L6
C8
C18
C15
R7
D4
CN2
E04-0154-05
RAT
RLS245
C16
RAT(B)
V08(G)
FINAL UNIT(ANT)
X45-365X-XX(C/3)[AT]
X45-366X-XX(C/3)[200W]
CN503
0V
D52
1000p
D2
L5
10u
470n
SWITCHING
R8
180
C13
-115dBm
BPF1
R51
ATT
0.1u
E18-0254-05
CN4
E40-5487-05
47
SWITCHING
BC
30K~1.705M
10k
R151
L77
C80
C59
470
2200p
6.8u
2200p
C57
C56
2200p
13.00V
13.02V
6.8u
1000u
56
R61
0V
Q51
KRA318E
BPF WAVE-FORM
D155
DAN235E
C191
12.63V
SWITCHING
0V
D60
HVC131
0.01u
RX POWER SUPPLY
CONTROL SWITCH
0.17V
DX
L57
R81
L56
Q152
RN47A5
SWITCHING
1000u
220p
Q302
KRC402E
1
TP1
RXB
33p
L68
1000u
C30
C78
SWITCHING
22
RXB
R185
RXB
1000p
RXB
0.01u
RXB
RATB
5.6k
RATB
C109
RATB
0.1u
RATB
1000p
C28
56
R18
0.1u
47k
RATB
2200p
10k
R10
SWITCHING
12.37V
CN51
E40-5487-05
CN152
E40-0211-05
7.64V
1k
R6
C1
1000p
C2
C32
NORM
470u16
R5
14S
470u16
E18-0254-05
MCF(B)
13.11V
13.19V
CN52
E40-5487-05
PRE GAIN
TC51
TC52
L51
L53
C129
C130
0-00
TS-480HX/480SAT
X44-327X-XX
K
NO
NO
NO
NO
NO
NO
2-71
TS-480HX/480SAT
E
C05-0385-05
C05-0385-05
6.8u
6.8u
9p
9p
TX-RX UNIT
X57-663X-XX(A/2)
CN1
A
1
B
C
D
E
TS-480HX/480SAT
F
G
H
I
PC BOARD
8
1
100W FINAL UNIT (X45-365X-XX) (A/3) 0-11 : KS 2-71 : ES
Component side view (J72-0875-09)
CN8
14V
14AF
14S
14AG
5V
8C
GND
GND
Q7
R33
C34
+
5
4
Q6
C30
+
8
+
R34
L12
C39
O
I
O
I
C44
GND 2
14AT 1
R42
IC2
R22
G
R19
R21
IC1
R17
CN5
GND 18 R20
FANH
FANL
IC1+
IC1–
R18
TH1
PCS1
FEN1
R7
DATA
R4
CLK
NC
R2
NC
TXB
NC R891
NC
NC
R1
ATL5
ATEN 1
CN2
G
2
J
TH1
1
CN13
3
R5
R3
R24
L16
F1
E
L35
CN12
E
R32
L17
R12
DIN2 5
L18
R30
L33
L7
C91
GND
1 DOUT2
GND
E
R54
C29
L14
L31
F2
C18
+
GND
BIN
Q4
C42
+
4 DOUT1
GND
C23
R56
R29
C19
L30
R47
L11
CN4
DIN1 1
C37
D2
B
+
L28
CN3
R57
C90
C33
L32
6
C74
R31
+
+
+
+
R58
C72
D
5
C
C76
C64
E
L34
Q3
D1
+
B
C67
Q2
R25
Q1
L29
L2
R49
R50
C63
G
S
D
L1
G
R16
C17
C10
R10
R8
R15
C13
R14
C14
4
VR3
L15
C6
VR1
CN7
CN6
CN1
DRV
C38
R59
C75
R60
B
Q5
R61
R23
R554
R51
VR2
7
L13
E
R28
L804
8
9
8
D806
D807
D808
CN820
AT IN
D805
D804
D803
D802
IC803
1
8
1
D891
16
IC801
8
1
Q891
D801
C822
9
16
9
C808
IC802
16
IC805
5 4
8 1
5 4
8 1
IC804
L801
9
C805
K809
K811
IN
L802
K891
K802
K804
K803
K805
K806
K807
C824
K801
K808
10
L803
C829
C827
C828
C837
C838
C840
C839
C823
C830
L805
11
C831
L806
OUT
C832
L821
L819
L817
L815
L813
CN819
AT OUT
L807
L811
L809
12
K810
13
J72-0875-09 A/3
86
14
K812
J
K
L
M
N
O
P
Q
R
S
TS-480HX/480SAT
PC BOARD
1
100W FINAL UNIT (X45-365X-XX) (A/3)
0-11 : KS 2-71 : ES
Component side view (J72-0875-09)
R35
2
C53
TH1
D3
C50
3
RED
Ref. No. Address
BLACK
E
B1+
W1
GND
B1+
C57
GND
+
L24
C95
D2
Q4
C
L90
E
C94
C49
R92
+
R36
L21
C46
C47
C77
R37
CN9
2
FAN1–
FAN1+
1
L20
L91
E
C96
C
Q5
C54
C52
C97
L27
C51
E
CN11
PO
+
K817
K815
K811
K819
K821
K813
K823
IC1
IC2
2F
2G
IC801
IC802
IC803
8F
8E
8G
IC804
IC805
Q1
8D
8D
4E
Q2
Q3
Q4
Q5
Q6
Q7
4D
4F
4J
6J
2I
2I
Q891
D1
D2
D3
D801
D802
D803
D804
D805
D806
D807
D808
D891
9D
4F
4J
3M
9D
9E
9F
9F
9G
9G
9H
9H
9E
4
5
6
7
8
9
C870
C863
C841
C861
828
C877
C856
C842
C849
829
10
C884
C869
C883
C871
C843
C855
C850
C839
11
C878
C862
C864
C838
C890
C872
C844
C888
12
K822
K820
K818
K812
K814
K816
K824
Component side
Layer 1
Layer 2
13
Foil side
87
14
A
1
B
C
D
E
TS-480HX/480SAT
F
G
H
I
K
L
CN8
14V
14AF
14S
14AG
5V
8C
GND
GND
IC2
Q7
5
4
Q6
C30
+
8
+
TH1
D3
F1
D1
E
L35
L90
C49
R92
+
R36
R37
L21
C46
C47
C77
L18
CN9
2
FAN1–
FAN1+
1
L20
R59
R60
B
C
Q5
C54
C52
E
E
L27
+
CN11
PO
R28
C51
R23
R554
R51
VR2
L13
C96
C97
C38
C75
E
L91
R32
E
R61
7
C94
R30
L17
R12
GND
1 DOUT2
GND
DIN2 5
L24
C
E
E
R54
C29
C18
C91
GND
BIN
Q4
L33
L7
+
L14
L31
F2
4 DOUT1
GND
C23
+
CN4
DIN1 1
+
C42
+
L28
CN3
GND
R29
C19
L30
R47
L11
L32
6
C57
+
+
+
B
R31
C33
B1+
R56
C90
C72
D
+
CN12
D2
R57
C37
C76
C64
C74
B1+
W1
GND
R58
L16
C
E
C95
B
Q3
E
L34
Q1
C67
+
R25
L29
L2
Q2
5
3
RED
BLACK
R49
R50
C63
L1
R16
C10
R10
R8
C17
G
C50
CN7
VR3
L804
8
9
16
8
1
8
IC801
IC803
C822
9
16
9
C808
1
8
1
Q891
K817
K815
D891
D805
D804
D803
D802
D806
D807
D808
CN820
AT IN
D801
9
C805
IC802
16
IC805
5 4
8 1
5 4
8 1
IC804
L801
K809
K811
K819
K821
K813
K823
K891
K802
K804
K803
K805
K806
K807
K808
C863
C841
C828
C856
C827
7
8
9
10
C884
C823
C883
C871
11
C878
C862
C839
C864
C840
C843
C850
C855
C838
C831
C837
C890
C872
C844
L806
C888
C832
L821
L819
L817
L815
L813
L811
L809
OUT
12
K822
CN819
AT OUT
K820
K818
K810
J72-0875-09 A/3
6
C869
L805
13
5
C877
C842
C829
C849
L803
L807
4
C870
C830
C861
C824
K801
10
12
Ref. No. Address
IC1
2F
IC2
2G
IC801
8F
IC802
8E
IC803
8G
IC804
8D
IC805
8D
Q1
4E
Q2
4D
Q3
4F
Q4
4J
Q5
6J
Q6
2I
Q7
2I
Q891
9D
D1
4F
D2
4J
D3
3M
D801
9D
D802
9E
D803
9F
D804
9F
D805
9G
D806
9G
D807
9H
D808
9H
D891
9E
IN
L802
11
1
1
L15
C6
C13
R14
C14
R15
TS-480HX/480SAT
C53
C34
S
2
R24
G
S
D
R
R35
R34
L12
C39
O
I
O
I
C44
GND 2
R5
VR1
Q
R33
+
CN6
CN1
DRV
P
100W FINAL UNIT (X45-365X-XX) (A/3)
0-11 : KS 2-71 : ES
Component side view (J72-0875-09)
CN13
R3
O
1
8
G
R22
IC1
R19
R21
14AT 1
R42
4
N
PC BOARD
G
R17
CN5
GND 18 R20
FANH
FANL
IC1+
IC1–
R18
TH1
PCS1
FEN1
R7
DATA
R4
CLK
NC
R2
NC
TXB
NC R891
NC
NC
R1
ATL5
ATEN 1
CN2
3
M
PC BOARD
100W FINAL UNIT (X45-365X-XX) (A/3) 0-11 : KS 2-71 : ES
Component side view (J72-0875-09)
2
J
K812
K814
K816
K824
Component side
Layer 1
Layer 2
13
Foil side
14
14
A
1
B
C
D
E
TS-480HX/480SAT
F
G
H
I
J
PC BOARD
100W FINAL UNIT (X45-365X-XX) (A/3) 0-11 : KS 2-71 : ES
Foil side view
(J72-0875-09)
L26
2
L25
L8
3
TH1
C22
C81
C80
4
C48
C78
C79
C59
Q9
C58
6
Q8
7
L829
C846
L823
C834
D810
D812
D813
C825
L826
C835
C851
C895
L827
C847
C853
C897
C857
D817
C896
C898
D815
C865
L831
D819
D821
C885
C859
C879
C873
L833
C867
C901
C887
L838
L835
C899
C875
C900
C881
8
C902
D823
9
10
11
12
D820
D818
C874
L834
C866
L832
C868
C907
C858
C852
L830
C845
C826
L824
C903
C848
C833
L825
C836
C854
L828
C904
C906
C860
D809
D811
D814
D816
C905
C876
C908
C909
C880
C882
C910
C889
88
L837
D822
D824
C886
14
L836
13
C32
C71
D4
C55
5
J
K
L
M
N
O
P
Q
R
S
TS-480HX/480SAT
PC BOARD
1
100W FINAL UNIT (X45-365X-XX) (A/3) 0-11 : KS 2-71 : ES
Foil side view (J72-0875-09)
2
C40
C43
C35
C27
Q11
C7
R52
Q10
S
D
G
R39
R38
3
C16
Ref. No. Address
Q8
6C
Q9
6C
L19
C41
R11
C45
C36
C65
C9
L36
R55
C28
C66
C21
C68
C73
C69
C32
C71
L6
C61
C62
C70
R53
C802
Q10
Q11
D4
3N
3N
5C
D809
D810
D811
13I
9I
13H
D812
D813
D814
D815
D816
D817
9H
9G
13G
8F
13F
8F
D818
D819
D820
D821
D822
D823
D824
13E
8E
13D
8D
13C
9C
13B
4
5
6
7
8
C894
C815
C893
C801
C820
9
L808
C804
C803
L891
C892
C891
L810
C807
C806
L812
C810
C809
L814
C812
C811
L816
C814
C813
C817
L818
C819
L820
C821
C816
C818
L822
10
11
12
Component side
6
J72-0875-09 A/3
Layer 1
Layer 2
13
Foil side
89
14
A
1
B
C
D
E
TS-480HX/480SAT
F
G
H
I
J
K
L
M
N
PC BOARD
O
P
R
S
TS-480HX/480SAT
PC BOARD
1
100W FINAL UNIT (X45-365X-XX) (A/3) 0-11 : KS 2-71 : ES
Foil side view (J72-0875-09)
100W FINAL UNIT (X45-365X-XX) (A/3) 0-11 : KS 2-71 : ES
Foil side view
(J72-0875-09)
2
L26
2
Q
C40
C43
C35
L25
C27
Q11
C7
R52
Q10
S
D
G
R39
L8
3
TH1
C22
R38
3
C16
L19
C81
C41
C80
C45
R11
4
C36
C65
C9
C28
C66
L6
C68
C73
C69
C32
C21
C79
C71
D4
C55
R55
C78
L36
C48
5
C59
C61
Q9
C62
C58
6
Q8
C70
R53
7
C802
L829
C846
L823
5
6
7
C893
C801
C834
D810
D812
D813
C894
C815
C825
L826
C835
C895
C851
C847
L827
D817
C896
C853
C897
C857
4
8
D815
C865
L831
D819
D821
C885
C898
C873
L833
C859
C879
C867
C901
C887
L838
L835
C899
C875
C900
C881
8
Ref. No. Address
Q8
6C
Q9
6C
Q10
3N
Q11
3N
D4
5C
D809
13I
D810
9I
D811 13H
D812
9H
D813
9G
D814 13G
D815
8F
D816
13F
D817
8F
D818 13E
D819
8E
D820 13D
D821
8D
D822 13C
D823
9C
D824 13B
C902
D823
9
C820
9
L808
C804
C803
L891
C892
C891
L810
C807
C806
L812
C810
C809
L814
C812
C811
L816
C814
C813
C817
L818
C819
L820
C821
C816
C818
L822
10
10
11
11
12
12
D820
C866
L832
C868
C907
D814
D816
C858
C852
L830
C845
C826
L824
J72-0875-09 A/3
C903
C848
C833
L825
C836
C854
L828
C904
C860
D809
D811
C905
C876
C906
C910
C889
14
C882
L834
C908
L837
C909
C886
C880
D824
D822
L836
13
Component side
D818
C874
Layer 1
Layer 2
13
Foil side
14
A
B
C
TS-480HX/480SAT
D
E
SCHEMATIC DIAGRAM
FINAL UNIT (X45-365X-XX)(A/3)[AT]
1
14S
4
5V
5
8C
6
14S
PCS1
TXB
14S
PCS1
TXB
L12
10u
AVR
GND
7
GND
8
IC1
TA7805F
SWITCHING
4.97V
4.98V
Q10
2SJ305
4.98V
2
1
OUT
3
3.47V
10k
AVR
IC2
TA7808F
3.19V
CN7
1
OUT
10u25
C39
R18
IN
GND
3.3k
C22
0.01u
TH1
157-153-53002
-t
F3
F06-4027-05
13.28V
2
5.6k
L8
0.01u
C27
2
SWITCHING
R20
TH1
7.91V
C35
CN6
14AT
GND
Q11
DTC114EKA
TH1
0.1u
CN5
E40-3246-05
1
C44
0.1u
C40
10u25
C34
2
22k
R38
R39
EXT.AT
13.27V
IN
GND
3
0.1u
3
FANH
FANL
IC1+
IC114V
0.1u
2
14AG
FANH
FANL
IC1+
IC114V
C43
14AF
C30
330u25
TX-RX UNIT
X57-663X-XX(A/2)
CN369
14V
CN8
E40-3252-05
1
DIN1
R12
R51
1.2k
C10
220
0.1u
C23
VR2
3.3k
C18
10u25
R10
BIN
680
0.1u
TXB
3
DIN2
R16
C17
T:1.43V
C6
R15
C13
22
0.1u
Q2
2SK2595
T:1.03V
15u
10
L1
R11
47
R8
330
0.1u
R3
T:13.13V
PRE-DRIVE AMP
L7
L39-1488-05
R5
10
47
CN1
DRV
R14
RF UNIT
X44-327X-XX
CN1
T:12.46V
Q1
2SK2596
0.1u
390
PRE-DRIVE AMP
T:2.49V
4
1.8A
F2
0.1u
C14
0.1u
10k
R50
22k
C63
R49
0.1u
L6
0.01u
C21
L30
L2
330u25
C66
VR1
3.3k
C16
1000p
C7
0.1u
FANH
FANL
IC1+
IC1PCS1
TXB
TH1
C19
R52
8.2k
L29
TX-RX UNIT
X57-663X-XX(A/2)
CN359
5
GND
18
FANH
17
FANL
16
1k
IC1+
15
R21
1k
IC1-
14
T:13.20V
47
R22
13
T:13.19V
47
12
T:2.42V
R42
FEN1
11
R7
47
DATA
10
47
R4
CLK
9
R2
47
NC
7
TXB
6
0.1u
C9
C65
R19
TH1
8
1000p
R17
PCS1
NC
10u25
C64
10u
FEN1
SIN
SCK
47
T:7.67V
6
NC
5
NC
4
NC
3
ATL5
2
ATEN
1
T:0V
R891
470
ATL5
R1
ATEN
47
CN2
E40-5978-05
D891
K891
Q891
L891
C891
C892
0-11
TS-480SAT
K
1SS355
S76-0415-05
DTC114EKA
47u
0.01u
0.01u
2-71
TS-480SAT
E
NO
NO
NO
NO
NO
NO
X45-365X-XX(A/3)
7
90
X45-365 (A/3) 1/3
14S
F
G
H
I
TS-480HX/480SAT
SCHEMATIC DIAGRAM
FINAL UNIT (X45-365X-XX) (A/3)
J
FANH
FANL
IC1+
IC114V
FANH
FANL
IC1+
IC114V
14S
PCS1
TXB
14S
PCS1
TXB
0.1u
VSS
GND
EN
A1
VCC
G1
3
1
4
4.98V
LAT
SCK
SIN
13
L[8]
IC805
TC7WT125FU
O8
O1
O7
O2
O6
O3
O5
O4
6
L[7]
4.98V
1
7
8
VCC
A1
G2
Y2
Y1
GND
A2
2
L[6]
C894
0.1u
G1
7
3
L15
L34
L35
R54
100
1W
C32
180p
C71
R23
100 2W
220p
0.01u
C69
1000p
L31
L32
10
L36
R55
0.01u
C72
0.22u50
560
R53
47p
C70
SCK
SO
SIN
L[1]
CO[8]
L[2]
CO[7]
L[3]
CO[6]
L[4]
CO[5]
O8
O1
O7
O2
O6
O3
O5
O4
6
13
4
0.1u
15
EN
RES
LAT
SCK
SO
SIN
O8
O1
O7
O2
O6
O3
O5
O4
14
13
12
5
CO[1]
CI[8]
CO[2]
CI[7]
CO[3]
CI[6]
CO[4]
CI[5]
CI[1]
11
6
CI[2]
10
7
CI[3]
9
8
9
C822
C815
3
10
8
9
14
11
7
16
4.98V
VDD
VSS
2
12
5
10
8
L[5]
LAT
4
11
IC803
UPD6345GS
1
15
3
12
16
RES
EN
14
5
BUFFER
VSS
RES
SO
4.98V
VDD
2
0.1u
G2
8
2
IC802
UPD6345GS
1
15
Y2
7
C893
0.1u
2
ATEN
16
C805
3
6
Y1
4.98V
VDD
C808
IC801
UPD6345GS
1
0.1u
330
1/4
0.1u
0.1u
0
T:13.28V
C7
R5
R554
22p
C3
4
A2
1
C73
Q2
2SK3075-H
DRIVE AMP
5
SCK
2
CN4
E40-5607-05
TC7WT125FU
ATEN
GND
L14
L39-1434-05
1000p
T:0.01V
IC804
BUFFER
3
L13
L39-1491-15
L28
L39-1485-05
330p
VOLTAGE
SHIFT
1
C9
C5
22p
R4
DIN2
R8
GND
DOUT2
3.3k
D1
27
R9
R10
D2
5
1SS388
DIN2
L33
1000p
4
C61
GND
DOUT1
0.1u
C62
4
330p
0.1u
C1
C8
BIN
C4
3
T:0.01V
22p
GND
R3
2
1
3.3k
1SS388
VOLTAGE
SHIFT
C10
27
C6
R7
22p
DRIVE AMP
Q1
2SK3075-H
DIN1
BIN
C29
T:13.28V
0.1u
100u25
C68
R6
330 1/4
C2
CN3
E40-5608-05
1
DIN1
0.1
2W
R47
SUB UNIT (X58-4900-01)
L39-1450-05
C67
22u25
C28
L11
CI[4]
6
4
EXTENDED I/O
5
EXTENDED I/O
EXTENDED I/O
FEN1
SIN
SCK
1.8M
3.5M
5M
L805
L806
L807
19.5T
15.5T
15.5T
L802
L801
19.5T 19.5T
L803
19.5T
7M
* K891
K801
10M
14M
L809
L811
L813
6.5T
3.5T
2.5T
K802
18M, 21M
24.9M
28M
50M
L815
L817
L819
L821
2.5T
2.5T
K807
K808
K804
K803
0.5T
2.5T
K805
K806
ATL5
ATEN
SURGE
ABSORPTION
D801 1SS355
C803
SURGE
ABSORPTION
0.01u
*
D891
*
C891
SURGE
ABSORPTION
SURGE
ABSORPTION
SURGE
ABSORPTION
SURGE
ABSORPTION
SURGE
ABSORPTION
SURGE
ABSORPTION
SURGE
ABSORPTION
D802
1SS355
D803
1SS355
D804
1SS355
D805
1SS355
D806
1SS355
D807
1SS355
D808
1SS355
0.01u
C809
0.01u
C811
0.01u
C813
0.01u
C816
0.01u
C818
0.01u
C820
0.01u
C806
L804
47u
L822
47u
L820
47u
L818
47u
L816
47u
L814
47u
L812
47u
0.01u
L[1]
C821
0.01u
L[2]
C819
0.01u
L[3]
C817
L[4]
C814
0.01u
L[5]
C812
0.01u
L[6]
C810
L[7]
0V
0.01u
SWITCHING
* Q891
C807
* C892
0V
0.01u
* L891
L808
47u
L[8]
0.01u
0.1u
C804
C802
1000p
C801
10u
L810
14S
91
X45-365 (A/3) 2/3, X58-490 1/1
K
L
M
TS-480HX/480SAT
N
O
SCHEMATIC DIAGRAM
FINAL UNIT (X45-365X-XX) (A/3)
FANH
FANL
IC1+
IC114V
FANH
FANL
IC1+
IC114V
14S
PCS1
TXB
14S
D4
SURGE ABSORPTION
CN9
E40-3246-05
0V
R58
1
C54
C55
0.1u
C81
GND
C77
270p
C47
330p
L21
L39-1490-05
T:0.69V
1
C873
C879
C885
0.01u
C902
L838
47u
CI[8]
0.01u
C887
0.01u
CI[7]
47u
0.01u
150p
C890
L835
0.01u
C881
0.01u
C888
47u
0.01u
150p
150p
0.01u
18p
C878
CI[6]
0.01u
L833
0.01u
C875
C871
150p
C872
150p
L831
0.01u
C867
0.01u
C864
18p
0.01u
C862
CI[4]
C859
0.01u
18p
0.01u
C855
CI[3]
0.01u
C853
0.01u
C850
10p
10p
10p
CI[2]
0.01u
C847
47u
L823
0.01u
CI[1]
C843
C844
10p
10p
10p
47u
0.01u
C898
C865
L829
0.01u
C897
C857
47u
0.01u
L827
C851
47u
0.01u
C896
C846
0.01u
L826
C834
C895
1SS355
C901
SURGE
ABSORPTION
D823 1SS355
D817
C900
SURGE
ABSORPTION
D821 1SS355
1SS355
47u
SURGE
ABSORPTION
D819 1SS355
D815
C899
SURGE
ABSORPTION
1SS355
CN819
AT OUT
K810
K812
K814
K816
K818
K820
K822
K824
SURGE
ABSORPTION
SURGE
ABSORPTION
D811 1SS355
SURGE
ABSORPTION
D814 1SS355
SURGE
ABSORPTION
D816 1SS355
SURGE
ABSORPTION
SURGE
ABSORPTION
D820 1SS355
SURGE
ABSORPTION
D822 1SS355
SURGE
ABSORPTION
D824
1SS355
0.01u
0.01u
C910
47u
CO[8]
0.01u
L837
0.01u
C889
47u
CO[7]
L836
0.01u
C882
C909
C886
0.01u
0.01u
47u
L834
0.01u
CO[6]
C908
C880
0.01u
0.01u
47u
C907
C874
CO[5]
C868
0.01u
L832
0.01u
C876
1SS355
0.01u
C906
47u
L830
0.01u
C866
CO[4]
C860
C905
47u
L828
0.01u
D818
0.01u
0.01u
C858
0.01u
C854
C904
C852
47u
L825
0.01u
0.01u
C903
47u
0.01u
CO[2]
0.01u
C845
CO[1]
C836
0.01u
L824
0.01u
C848
1SS355
FINAL UNIT (ANT)
X45-365X-XX(C/3)[AT]
CN504
C884 150p
150p
C883 150p
10p
C52
10p
C51
C877
C869
150p
C870
150p
18p
C863
C861
18p
47p
K823
10p
C840 C839 C838 C837
K821
D813
C835
C825
10p
K819
1SS355
0.01u
C831
10p
C832
SURGE
ABSORPTION
SURGE
ABSORPTION
K817
D812
C833
C826
SURGE
ABSORPTION
K815
SURGE
ABSORPTION
D810 1SS355
D809
X45-365 (A/3) 3/3
K813
K811
CI[5]
10p
10p
CN820
ATIN
K809
92
C856 18p
10p
10p
C849 10p
C841
C842
C827
10p
C829
C830
10p
C828
C823 10p
C824 10p
C96
82 3W
0.01u
CN11
E04-0154-05
PO
L27
L34-1231-15
L39-0421-04
R91
100p
C97
1
C91
T:13.19V
0.01u
2.2 1W
Q5
2SC2782
L91
CO[3]
R61
0.01u
1
R28
C93
FINAL AMP
3300p
FINAL UNIT (FILTER)
X45-365X-XX(B/3)[AT]
CN102
R60
FINAL UNIT (ANT)
X45-365X-XX(C/3)[AT]
CN505
C75
SURGE ABSORPTION
10
1/4W
L39-1451-05
R32
L18
1/2W
R30
8.2 1/2W
R59
3300p
C38
DC13.8V
R29
8.2
L17
B1+
GND
10
1/4W
C74
3300p
L16
R31
1
W1
ZSH5MA27
D3
C57
0.1u
470p
0.01
10W
FINAL AMP
3300p
470u25
R37
33 1/4W
0.01u
C59
Q8,9
B1+
C80
0.01u
1000p
C79
100u25
C78
C48
Q4
2SC2782
0.1u
C49
R57
T:0.69V
L20
C37
T:13.19V
C94
1
C92
R56
0.01u
R25
12.68V
SWITCHING
R35
L33-0617-15
47p
L90
L39-0421-04
82 3W
100p
C95
0.01u
2.2 1W
4.7 1W
L24
MA27-B
1000p
C50
MA27-B
R90
L26
4.7u
C41
0.1u
C90
L25
R92
VR3
3.3k
56 1/2W
R36
D2
CN13
C58
0.01u
L19
D1
CN12
FAN
FAN1+
Q9
2SD1757K
Q8
2SD1757K
C53
T:1.41V
390
1/8W
0V
470u25
C45
Q6
SI7445DP
SWITCHING
D1,2
0V
T:13.19V
TEMPERATURE
COMPENSATION
R24
FAN11
12.67V
5A
0.1u
C42
220u25
C76
10k
T:13.16V
Q3
2SC3421(Y)
0.01u
C36
0.1u
C33
10u25
T:4.14V
F1
BIAS CONTROL
T:0.73V
R33
T:13.18V
22k
Q7
DTC114EKA
R34
3.19V
0.1u
D4
1SS355
2
SWITCHING
FINAL UNIT (X45-365X-XX)(A/3)[AT]
FANH
FANL
IC1+
IC114V
14S
PCS1
TXB
14S
PCS1
TXB
14S
PCS1
TXB
14S
PCS1
TXB
14S
PCS1
TXB
14S
1
R891
470
R1
ATL5
ATL5
ATEN
ATEN
C77
O3
O5
O4
C851
0.01u
C857
0.01u
C865
0.01u
0.01u
0.01u
47u
C902
L838
0.01u
47u
C901
L835
0.01u
C900
47u
L833
0.01u
47u
C899
L831
0.01u
C898
C897
47u
L827
0.01u
47u
C896
L826
0.01u
47u
CI[4]
C895
*
K891
3.5T
2.5T
K802
SURGE
ABSORPTION
* D891
0.01u
6.5T
* C891
0.01u
28M
50M
L817
L819
L821
2.5T
2.5T
K807
K808
K810
K812
K814
K816
K818
K820
K822
K824
SURGE
ABSORPTION
D811 1SS355
SURGE
ABSORPTION
D814 1SS355
SURGE
ABSORPTION
D816 1SS355
SURGE
ABSORPTION
SURGE
ABSORPTION
D820 1SS355
SURGE
ABSORPTION
D822 1SS355
SURGE
ABSORPTION
0.5T
2.5T
K805
K806
CI[8]
C887
150p
CI[7]
C890
0.01u
150p
CI[6]
C875
0.01u
CI[5]
C867
0.01u
C859
0.01u
24.9M
L815
CN819
AT OUT
SURGE
ABSORPTION
SURGE
ABSORPTION
SURGE
ABSORPTION
SURGE
ABSORPTION
SURGE
ABSORPTION
SURGE
ABSORPTION
SURGE
ABSORPTION
SURGE
ABSORPTION
D802
1SS355
D803
1SS355
D804
1SS355
D805
1SS355
D806
1SS355
D807
1SS355
D808
1SS355
D809
0.01u
C809
0.01u
C811
0.01u
C813
0.01u
C816
0.01u
C818
0.01u
C820
0.01u
C806
CI[3]
18M, 21M
K804
K803
C881
15.5T
14M
L813
C888
15.5T
10M
L811
150p
19.5T
7M
L809
C853
EXTENDED I/O
EXTENDED I/O
C878
L807
C803
C833
1SS355
0.01u
C845
0.01u
C852
0.01u
C858
D818
0.01u
C866
1SS355
0.01u
C874
C880
0.01u
D824
C886
0.01u
1SS355
0.01u
0.01u
C910
47u
L837
0.01u
CO[8]
0.01u
C889
C909
47u
CO[7]
L836
0.01u
0.01u
C882
C908
47u
CO[6]
L834
C876
0.01u
0.01u
C907
47u
CO[5]
L832
C868
0.01u
0.01u
C906
47u
L830
0.01u
CO[4]
C860
C905
0.01u
47u
L828
0.01u
CO[3]
0.01u
C854
C904
47u
L825
0.01u
CO[2]
0.01u
C848
C903
47u
L824
0.01u
CO[1]
0.01u
C836
0.01u
L[1]
C821
0.01u
L[2]
C819
L[3]
C817
0.01u
L[4]
C814
L[5]
0V
0.01u
SWITCHING
* Q891
C826
47u
L822
47u
L820
47u
L818
47u
L816
47u
L814
0V
0.01u
NO
C812
NO
47u
NO
L812
NO
0.01u
NO
L[6]
NO
C810
E
47u
TS-480SAT
L[7]
2-71
10u
L810
0.01u
C807
0.01u
0.01u
47u
* L891
DTC114EKA
* C892
S76-0415-05
47u
1SS355
L808
K
0.01u
TS-480SAT
L[8]
0-11
0.1u
C892
C804
C891
C802
L891
14S
1000p
Q891
FINAL UNIT (FILTER)
X45-365X-XX(B/3)[AT]
CN102
CI[3]
9
8
L804
K891
FINAL UNIT (ANT)
X45-365X-XX(C/3)[AT]
CN504
0.01u
10
7
150p
5M
L806
SURGE
ABSORPTION
D801 1SS355
D891
C55
C884 150p
150p
C883 150p
10p
C52
10p
C51
150p
150p
C877
C869
C870
18p
C863
18p
C861
0.01u
150p
3.5M
L805
K801
47
X45-365X-XX(A/3)
0.1u
C81
270p
330p
C47
C96
100p
C97
C856 18p
10p
10p
C849 10p
C841
C842
47p
C885
C846
0.01u
CI[2]
C871
19.5T
CN2
E40-5978-05
14S
0.1u
D4
1SS355
C54
0.01u
ZSH5MA27
D3
470p
C53
C57
10
1/4W
10
1/4W
R31
L39-1451-05
R32
330p
470u25
R37
33 1/4W
R36
C59
C58
0.01u
L26
L25
0.1u
C80
0.01u
1000p
C79
100u25
C78
470u25
C45
56 1/2W
10k
0.1u
C49
L20
C48
47p
C94
100p
C95
1000p
C50
C41
0.1u
C827
10p
10p
10p
10p
C828
C829
C830
C824 10p
0.1u
C879
C822
C815
0.1u
C808
L30
L802
T:0V
C93
C72
0.22u50
O6
CI[1]
11
FINAL UNIT (ANT)
X45-365X-XX(C/3)[AT]
CN505
ATEN
0.1u
0.01u
C21
330u25
C66
1.8M
L803
L801
2
C873
C834
12
47
19.5T 19.5T
3
ATL5
EXTENDED I/O
5
T:7.67V
NC
O2
1SS355
C872
4
SURGE
ABSORPTION
D823 1SS355
D817
18p
5
NC
CI[5]
SURGE
ABSORPTION
D821 1SS355
1SS355
C864
NC
CI[6]
CO[4]
9
SURGE
ABSORPTION
D819 1SS355
D815
18p
6
CO[3]
10
SURGE
ABSORPTION
1SS355
18p
7
O4
O1
O7
SURGE
ABSORPTION
SURGE
ABSORPTION
D813
C855
NC
TXB
SCK
O4
K823
1SS355
10p
8
SIN
SCK
O3
O5
8
SIN
O8
SURGE
ABSORPTION
0.01u
NC
SIN
O6
7
CI[7]
K821
D812
CI[2]
47
A2
CO[5]
SO
6
CO[2]
K819
SURGE
ABSORPTION
D810 1SS355
C850
R4
R2
GND
CO[6]
L[4]
13
C847
47
9
FEN1
L[3]
9
SCK
14
CI[8]
11
K817
6
4
FEN1
O2
LAT
10p
10
CLK
R42
CO[7]
10
O5
O7
RES
5
CO[1]
K815
15
EN
10p
DATA
Y1
O3
O1
K813
K811
0.01u
47
Y2
3
O6
8
L[5]
SIN
O8
6
L[2]
4
CN820
ATIN
K809
C835
R7
G2
O2
13
CN11
E04-0154-05
PO
L27
L34-1231-15
82 3W
10p
11
L[6]
7
A1
O7
3
12
CO[8]
11
7
8
VCC
L[1]
14
T:13.19V
10p
12
FEN1
L[7]
4.98V
SO
5
12
6
1
G1
PCS1
O1
L21
L39-1490-05
L39-0421-04
R91
10p
T:2.42V
IC805
TC7WT125FU
2
47
SIN
O8
16
4.98V
VDD
VSS
2
SCK
LAT
4
GND
10p
T:13.19V
1
C840 C839 C838 C837
R22
L18
R54
100
1W
C32
180p
220p
L36
10
R55
R53
C70
47p
0.1u
C62
C61
560
2.2 1W
C831
1k
47
SO
3
DC13.8V
SURGE ABSORPTION
Q5
2SC2782
L91
L823
G1
5
BUFFER
R19
R21
R61
C823 10p
VCC
13
1
RES
EN
SCK
LAT
4.98V
C801
TX-RX UNIT
X57-663X-XX(A/2)
CN359
13
T:13.20V
1
R28
10p
14
3300p
C825
4
16
B1+
FINAL AMP
IC803
UPD6345GS
15
2
W1
B1+
0.01
10W
GND
T:0.69V
1
0.01u
1
4.98V
VDD
VSS
14
A1
8
1
0.1u
G2
3
16
RES
EN
2
IC802
UPD6345GS
15
Y2
7
C893
0.1u
2
ATEN
Q8,9
R60
10p
15
IC1-
8.2 1/2W
R59
3300p
C38
0.1u
L6
3
Y1
4.98V
VDD
VSS
GND
C894
0.1u
IC1+
TH1
1k
1/2W
C91
1
4
A2
6
SCK
0.1u
C9
C65
1000p
5
ATEN
L29
R17
16
1
R30
C75
IC801
UPD6345GS
TC7WT125FU
L[8]
FANL
R29
R554
T:13.28V
IC804
BUFFER
Q4
2SC2782
0
C805
17
10u25
C64
FANH
3300p
L16
8.2
1.8A
F2
0.1u
C19
VR1
3.3k
C16
1000p
0.1u
C7
18
R58
C832
PRE-DRIVE AMP
10u
GND
1
C74
L7
L39-1488-05
47
C14
C63
0.1u
10k
R50
FANH
FANL
IC1+
IC1PCS1
TXB
TH1
L2
3300p
L17
R52
8.2k
C92
L34
C71
100 2W
R23
1
330p
C9
L35
L33
2
R49
22k
R57
T:13.19V
12.68V
SWITCHING
R35
L33-0617-15
T:0.69V
0.01u
L15
L39-1450-05
0.1
2W
R47
1000p
L31
L32
0.01u
C69
C29
22p
C8
C4
22p
R3
3.3k
R5
330
1/4
1
0.01u
Q2
2SK2595
R14
15u
10
L1
R11
C3
0.1u
R56
CI[1]
0.1u
GND
L14
L39-1434-05
0.01u
T:13.13V
L90
L39-0421-04
C843
22
3
CN4
E40-5607-05
Q2
2SK3075-H
R25
2.2 1W
4.7 1W
L24
R90
C844
C13
T:0.01V
DRIVE AMP
D2
CN13
MA27-B
82 3W
C37
C73
C17
R15
T:1.03V
47
R8
330
1
T:1.43V
0.1u
R3
0.1u
T:12.46V
C6
GND
L13
L39-1491-15
L28
L39-1485-05
4
DOUT1
DOUT2
VOLTAGE
SHIFT
C7
R8
390
Q1
2SK2596
T:2.49V
R5
10
C6
DIN2
C90
0.01u
22p
0.1u
D1
5
R16
220
1SS388
R9
1000p
C10
PRE-DRIVE AMP
27
GND
22p
DIN2
BIN
4
R4
DIN2
3
0.1u
C1
L19
4.7u
MA27-B
FAN
FAN1+
Q9
2SD1757K
Q8
2SD1757K
R92
VR3
3.3k
0V
FINAL AMP
T:0.01V
3.3k
BIN
VOLTAGE
SHIFT
C10
C5
0.1u
C23
VR2
3.3k
C18
GND
680
10u25
R10
BIN
DIN1
2
1
27
R51
CN3
E40-5608-05
1
DIN1
R10
R12
1.2k
RF UNIT
X44-327X-XX
CN1
DRIVE AMP
Q1
2SK3075-H
D2
DIN1
TXB
T:13.28V
0.1u
100u25
C68
0.1u
10u25
C39
0.1u
R18
3.3k
C22
GND
3
R7
CN1
DRV
R6
330 1/4
C2
1SS388
F3
F06-4027-05
1
IN
390
1/8W
1000p
5.6k
0.01u
-t
TH1
157-153-53002
GND
13.28V
2
OUT
L8
0.01u
C27
2
SWITCHING
R20
TH1
SUB UNIT (X58-4900-01)
D1
CN12
R24
C43
CN7
7.91V
C35
CN6
14AT
EXT.AT
Q11
DTC114EKA
TH1
0.01u
AVR
IC2
TA7808F
3.19V
CN5
E40-3246-05
1
Q6
SI7445DP
SWITCHING
D1,2
0V
T:13.19V
TEMPERATURE
COMPENSATION
T:1.41V
FAN11
12.67V
5A
0.1u
C42
C36
220u25
3.47V
10k
T:13.16V
Q3
2SC3421(Y)
C76
C44
0.1u
C40
10u25
3
T:0.73V
C33
10u25
R39
22k
R38
C34
8
T:4.14V
F1
BIAS CONTROL
L11
13.27V
IN
GND
R33
1
OUT
22k
T:13.18V
2
0.01u
4.98V
0.1u
4.98V
Q10
2SJ305
R34
IC1
TA7805F
SWITCHING
4.97V
0.1u
7
C67
6
Q7
DTC114EKA
AVR
22u25
C28
8C
GND
GND
2
SWITCHING
0.1u
5
CN9
E40-3246-05
0V
0.01u
10u
3.19V
5V
D4
SURGE ABSORPTION
L12
47u
4
FANH
FANL
IC1+
IC114V
L829
14S
FANH
FANL
IC1+
IC114V
0.01u
3
FANH
FANL
IC1+
IC114V
CI[4]
14AG
FANH
FANL
IC1+
IC114V
C862
2
FANH
FANL
IC1+
IC114V
0.01u
14AF
C30
330u25
TX-RX UNIT
X57-663X-XX(A/2)
CN369
14V
CN8
E40-3252-05
1
P
Q
R
S
T
TS-480HX/480SAT
SCHEMATIC DIAGRAM
1
L103
L39-1260-05
K102
POUT
Land & Wire
C108
68p
POUT
1000p
820p
1000p
68p
C104
C107 120p
C109
C102
0
L101
47u
560p
C105
R102
C103
C106
PIN
1000p
CN102
D101
1SS355
C111
0.01u
GND
Land & Wire
GND
GND
Land & Wire
GND
GND
Land & Wire
GND
GND
Land & Wire
GND
GND
Land & Wire
GND
1.705~2.5
D101
SURGE ABSORPTION
1000p
C158 560p
L151
47u
C157 150p
C155
330p
C152
560p
C154
K152
L153
L152
K151
D151
FINAL UNIT (ANT)
X45-365X-XX(C/3)[AT]
L102
L39-1259-05
K101
CN11
FINAL UNIT
X45-365X-XX(A/3)[AT]
FINAL UNIT (FILTER) (X45-365X-XX)(B/3) [AT] 0-11:TS-480SAT(K) 2-71:TS-480SAT(E)
2
1SS355
C159
0.01u
2.5~4.7
D151
C206
68p
C209
C207
56p
C212
39p
C93-0570-05
120p
K202
C210 390p
560p
C202 180p
L201
47u
C203 120p
C204
68p
L204
L39-1223-05
L202
L39-1266-05
K201
C208 680p
L203
L39-1223-05
C205
SURGE ABSORPTION
D201
1SS355
C211
0.01u
3
4.7~7.5
D201
SURGE ABSORPTION
10p
270p
C259
220p
C257
D251
1SS355
C260
0.01u
7.5~10.5
28M
6
0V
7M
5
0V
2M
4
0V
21M
3
0V
GND
2
4
SURGE ABSORPTION
L301
47u
L304
L39-1221-05
L303
L39-1221-05
L302
L34-1278-05
K301
C306
27p
C309
56p
C312
4p
K302
C310 180p
13.12V
270p
0V
7
C307
8
C304 180p
4M
1
C258 100p
K252
D251
14M
C93-0554-05
D301
1SS355
C311
0.01u
10.5~14.5
1.82V
D301
SURGE ABSORPTION
LED
D100
L351
47u
C354
8p
C356
47p
C357 150p
100p
0
C352
R105
K352
L353
L34-1280-05
L352
L34-1279-05
K351
C355 270p
B30-2263-15
C93-0558-05
D351
1SS355
C359
0.01u
5
14.5~21.5
D351
SURGE ABSORPTION
18p
0
C410
C413
C407
C412
5p
C404
L401
47u
C408
K402
82p
C405
56p
18p
C403
L404
L34-1281-05
150p
L403
L34-1281-05
15p
33p
R103
L402
L34-4661-05
120p
K401
C402
D401
1SS355
C411
0.01u
6
L405
21.5~30.0
D401
SURGE ABSORPTION
C451
L451
47u
0.01u
C454
5p
C93-0555-05
C456
56p
0
C458
C461 18p
18p
C93-0563-05
K452
L454
L34-1359-05
C459
R104
L453
L34-4491-05
C93-0563-05
C462 22p
L452
L34-4662-05
K451
56p
LED
L251
47u
220p
0V
C255
9
C252
0V
22p
FINAL UNIT (ANT)
X45-365X-XX(C/3)[AT]
CN501
10M
10
C452
50M
C254 47p
0
C256
150p
R101
CN101
E40-5734-05
L253
L39-1221-05
L252
L39-1221-05
K251
D451
1SS355
C463
0.01u
L455
49.0~54.0
D451
SURGE ABSORPTION
7
93
X45-365 (B/3) 1/1
A
1
B
C
D
E
TS-480HX/480SAT
F
G
H
I
J
PC BOARD
100W FINAL UNIT (X45-365X-XX) (B/3) 0-11 : KS 2-71 : ES
Component side view (J72-0875-09)
C306
L303
CN102
PIN
L302
C304
C310
C307
L304
3
BLUE
2
J72-0875-09 B/3
C202
C204
K201
C252
L252
C254
L202
L203
C255
C259
C258
L253
K202
5
C256
C210
K302
L204
4
C203
K301
K251
L352
C355
K352
K351
C352
L353
C357
6
C356
K252
C107
L103
C108
K102
L102
K101
7
C104
C402
C404
L402
K151
L152
C154
C157
10
Ref No. Address
D100
13
9J
R105
7M
21M
2M
GND
C452
14M
4M
10M
12
28M
L452
50M
C459
C456
11
K451
L454
L453
C462
K452
L455
LED
K152
L153
9
K401
D100
C405
L403
C410
L404
C407
C408
L405
C403
K402
8
Component side
Layer 1
Layer 2
Foil side
94
14
B
C
D
E
F
G
H
I
J
TS-480HX/480SAT
PC BOARD
1
100W FINAL UNIT (X45-365X-XX) (B/3) 0-11 : KS 2-71 : ES
Foil side view (J72-0875-09)
2
C309
C312
3
L301
J72-0875-09 B/3
D301
C311
D201
C211
C260
C257
D251
C209
C207
C206
4
5
6
C359
C411
C111
7
C413
8
C412
L401
R103
C106
D401
C105
C109
D101
C103
C102
L101
R102
D351
C354
L351
L251
R101
L201
C205
C208
C212
L151
C159
D151
C158
R104
C152
C155
9
C451
L451
D451
10
C463
C454
C458
C461
11
W501
Ref No. Address Ref No. Address
D101
7I
D301
4I
D151
10I
D351
6I
D201
D251
5I
6I
W505
W504
W503
W502
1 LED
GND 2
21M
2M
7M
28M
14M
4M
9 10M
50M 10
W506
CN101
A
D401
D451
8I
10J
12
Component side
Layer 1
Layer 2
13
Foil side
95
14
A
1
B
C
D
E
TS-480HX/480SAT
F
G
H
I
J
PC BOARD
100W FINAL UNIT (X45-365X-XX) (C/3) 0-11 : KS 2-71 : ES
Component side view (J72-0875-09)
R531
R533
20
R534
51
L503
1 50M
10M
4M
14M
28M
7M
2M
21M
GND
10 LED
43
51
W503
W502
W504
D505
W505
Ref No. Address Ref No. Address Ref No. Address Ref No. Address Ref No. Address Ref No. Address
IC501
2H
IC510
5H
Q504
3I
Q508
4G
D504
6H
D508
4C
IC502
5I
Q501
3G
Q505
2H
D501
5B
D505
6H
D509
3D
IC503
4H
Q502
3H
Q506
5G
D502
5C
D506
3E
IC509
5H
Q503
3H
Q507
5H
D503
4F
D507
3E
R532
3 4
L510
R539
IC502 C530
1 5
AMD
C523
G
R513
D
C512
R511
Q507
S
R515 R514
L506
R509
W501
4 5
IC503
1 8
D504
L505
C519
R517
R508
W506
IC510
5 1
C522
VR501
4 3
C514
C537
VSF
C507
C511
R521
34
IC509
C520 R520
C525
Q506
D
G
S
L511
1 5
C536
R512
D502
D501
R516
R510
CN503
RAT
C513
L504
L502
+
C517 C516
K501
L501
BLACK
D508
R550
R530
C528
4
C521
Q508
L507
CN505
AT OUT
GND
C527
C515
D503
C526
K503
1 GND
TXB
VSR
VSF
VSR PHD
AMD
GND
FEN2
CLK
DATA
14S
12 5C
C535
CN501
ANT1
TC501
51
51
Q503
43
51
K502
Q502
43
Q501
43
D506
D507
C518
3
7
Q504
43
L508
6
1
10
5 1
D509
GND
5
IC501
ANT2
Q505
4 3
L509
YELLOW
CN504
AT IN
11
J72-0875-09 C/3
CN502
2
VR502
R518
R519
Component side
Layer 1
Layer 2
Foil side
100W FINAL UNIT (X45-365X-XX) (C/3) 0-11 : KS 2-71 : ES
Foil side view (J72-0875-09)
8
R505
C508
9
R506
10
R507
R504
R503
C529
C531
R502
C504
C509
R501
C503
C502
R537
R535
R552
R538
12
C505
R536
C506
11
R553
J72-0875-09 C/3
13
Component side
Layer 1
Layer 2
96
14
Foil side
A
B
C
D
E
TS-480HX/480SAT
SCHEMATIC DIAGRAM
1
FINAL UNIT (ANT)(X45-365X-XX)(C/3)[AT] 0-11:TS-480SAT(K) 2-71:TS-480SAT(E)
C537 8p
POUT
Land & Wire
W501
C531
47p
47p
C529
100k
100k
R537
D508
DSA301LA
R535
D507
ANT
GND
SURGE
ABSORPTION
GND
2
100k
100k
R538
DSA301LA
R536
D509
ANT1
47u
L509
RF UNIT
X44-327X-XX
CN2
ANT2
D507-509
SURGE
ABSORPTION
L507
47u
RAT
1SS355
C526
0.01u
D506
D503,506
0.01u
1000p
C509
1SS355
C518
0.01u
ATS
C508
56p
VDET
L508
C503
R504
HIGH-FREQUENCY
RECTIFICATION
0.01u
IDET
C515
VR501
220
R503
27 1/2W
D501,502
GND
W505
0
GND
Land & Wire
33 1/2W
R502
10
68p
C504
R501
W504
0
GND
Land & Wire
C502
GND
VSF
D503
1SS355
47u
1m
100
1m
GND
R505
39
R506
L504
R507
3p
D502
1SS348
100
D501
1SS348
L501
150n
K503
S76-0424-05
K502
S76-0424-05
1k
W502
0
GND
Land & Wire
1000p
FINAL UNIT (FILTER)
X45-365X-XX(B/3)[AT]
C507
TC501
10p
GND
Land & Wire
GND
L511
L506
L505
0
W503
0
GND
Land & Wire
CN503
K501
L502
POUT
VSR
GND
W506
0
CN505
ATOUT
FINAL UNIT
X45-365X-XX(A/3)[AT]
CN819
DRIVER
CN504
ATIN
13.19V
Q508
RN47A5
R:0V
T:13.07V
R:0.18V
T:7.71V
FINAL UNIT
X45-365X-XX(A/3)[AT]
CN820
13.19V
L503
3
C530
0.01u
0.01u
4.70V
0.01u
C513
C521
0.1u
C506
1000p
C505
10u
SIGNAL AMP
Q506
2SK208(GR)
0V
R510
0.01u
100
DRIVER
Q505
FMA5A
13.07V
INVERTER
VDET
0V
ATS’
1
C520
1.00V
0.36V
R:13.08V
T:13.02V
4.70V
IC509
TC7SHU04F
100k
C511
R512
Q501-505
2
3
0.01u
ANT’
D FLIP-FLOP
5
NC
VCC
IC503
TC7WH74FU
IN
1
4
GND
8
CK
oUT
VCC
R520
13.07V
PR
Q
CLR
6
4
PHD
5
GND
Q
1M
50M’
0V
4.70V
7
D
3
1.5k
C536
10p
Q501
FMA5A
0V
R516
2
4
13.07V
Q503
FMA5A
0V
0V
0.01u
C525
19
OE
18
DATA
SO
CLK
Q11
LCK
Q10
3
VSR
VSF
4
D505
HSM88AS
HIGH-FREQUENCY
RECTIFICATION
IC502
TA75S393F
VSF
PHD
5
PHD
1
2
3
IN-
5
4.70V
4
R532
VCC
VEE
IN+
OUT
AMD
6
AMD
GND
7
1k
GND
FEN2
8
FEN2
100
R531
CLK
9
CLK
100
R534
DATA 10
DATA
R533
100
AMD
100
14S
11
14S
5C
12
5C
TX-RX UNIT
X57-663X-XX(A/2)
CN375
VSR
17
21M’
16
5
2M’
15
6
Q0
Q9
Q1
Q8
7M’
14
7
28M’
13
8
Q2
9
Q3
10
Q4
0.36V
13.07V
13.07V
14M’
Q7
12
4M’
Q6
11
Q5
10M’
13.07V
13.07V
13.07V
C535
4
ATS’
R515
VDD
3
ANT’
IDET
3.54V
1k
20
2
TXB
R539
R519
COMPARATOR
R530
R514
1k
R509
1
GND
2
15k
R518
1k
VDET
EXTENDED I/O
IC501
BU2099FV
1
TXB
L510
47u
R508
5
GND
D504
HSM88AS
13.07V
21M’
50M’
0.01u
HIGH-FREQUENCY
RECTIFICATION
1000p
0V
NC
10k
R517
13.07V
2M’
VSS
CN502
E40-5758-05
1M
Q504
FMA5A
0V
LED
1.82V
oUT
R521
6
0.01u
10
GND
0.01u
LED
7M’
21M
GND
4
C527
9
IN
3
47u 16
C528
8
GND
4.70V
VCC
2
13.07V
2M
21M
C522
0.01u
7M
5
NC
C519
0.01u
1.8k
7
1
0.99V
28M’
R553
6
2M
IC510
TC7SHU04F
13.07V
28M
4.7k
7M
100
1.5k
5
0.01u
IDET
13.12V
VR502
22k
28M
INVERTER
14M’
4M
14M
C523
4
0.01u
14M
10M
R511
0.01u
3
0V
C512
100k
4M
Q507
2SK208(GR)
4M’
0.36V
10k
C516
2
10k
C517
10M
4.70V
SIGNAL AMP
13.07V
R513
CN501
E40-5739-05
1
50M
0V
R552
FINAL UNIT (FILTER)
X45-365X-XX(B/3)[AT]
CN101
50M
C514
10M’
Q502
FMA5A
13.07V
0.36V
13.07V
13.07V
R550
390
7
97
X45-365 (C/3) 1/1
A
1
B
C
D
E
TS-480HX/480SAT
F
G
H
I
PC BOARD
8
1
200W FINAL UNIT (X45-366X-XX) (A/3) 0-00 : KH 2-71 : EH
Component side view (J72-0876-09)
CN8
14V
14AF
14AG
5V
14S
8C
GND
Q7
R37
+
C34
8
+
R3
L3
CN6
CN1
DRV
E
C68
Q1
Q3
B
L16
G
S
D
L15
C14
C
R12
C36
+
CN12
R51
C66
R50
C40
R49
D3
B
C72
Q4
R35
C39
C8
C67
C75
L2
C17 R17
L28
E
L1
D
R14
R7
D2
R10 C10
C13
R15
Q2
R29
R28
R9
G
CN7
VR3
C4
VR1
R16
TH1
1
CN13
R2
R5
4
4
Q6
R21
3
5
R38
C42
O
C37
L13
IC2
I
O
I
C47
+
GND
G
R24
IC1
R22
R23
14AT 1
CN5
R18
R20
GND 2
GND 18 R26
FANH
FANL
IC1+
IC1–
TH1
R25
PCS1
NC
NC R11
NC
VDT2 R66
ODP
TXB
TH2
R6
IC2–
IC2+
R4
PCS2
NC 1 R1
CN2
G
2
J
E
+
L9
R33
C20
C27
R90
L18
R81
+
+
L14
F4
5
R34
L27
L7
CN3
CN4
DIN1 1
C22
C18
GND
GND
1 DOUT2
DIN2 5
R80
C80
L5
VR2
7
C76
GND
BIN
L17
R13
+
E
4 DOUT1
GND
R36
6
L12
C71
R52
C70
R53
C69
R54
B
C41
Q5
E
R32
8
C801
R805
9
VR802
C841
L805
L823
D807
C832
R826
C831
R825
C830
R824
E
Q804
B
C
R838
R837
R811
C829
C842
C843
10
E
C808
L802
E
E
R836
L822
R809
L810
C800
C811
C812
C823
R810
R839
VR801
L804
L821
L806
R827
C834
R828
C833
R829
Q805
B
C
R841
BLACK
D803
E
R808
1
IC3
CN829
GND
E
D806
G
F801
E
C821
I
5
4
Q806
8
E
L807
98
C835
C809
C
O
13
D802
Q803
+
C838
B
C807
+
E
R840
CN830
C836
R812
C828
+
C803
+
12
14
L808
L803
R800
11
GND
W801
J
K
L
M
N
O
P
Q
R
S
TS-480HX/480SAT
PC BOARD
1
200W FINAL UNIT (X45-366X-XX) (A/3)
0-00 : KH 2-71 : EH
Component side view (J72-0876-09)
R39
2
C56
TH1
D5
C53
3
RED
Ref. No. Address
BLACK
E
W1
GND
B1+
B1+
C63
GND
+
D3
L24
C
Q4
R60
R59
E
C52
+
R58
R40
FAN1+
1
R43
R41
L20
R61
R62
CN10
2
FAN2–
R63
C
Q5
R42
L21
C81
C49
C50
C60
E
CN9
2
FAN1–
FAN2+
1
C54
E
+
L818
IC1
IC2
2F
2G
IC3
Q1
Q2
13D
4E
4D
Q3
Q4
Q5
4F
4J
6J
Q6
Q7
Q803
Q804
Q805
Q806
2I
2I
13C
9G
12G
13E
D2
D3
D5
D802
D803
D806
D807
4F
4J
3M
13C
12G
13I
10C
4
5
6
7
8
R816
9
C819
L820
L809
10
GND
PO
L810
11
C816
+
L814
CK
RED
W801
C822
GND
B2+
B2+
12
J72-0876-09 A/3
+
Component side
Layer 1
Layer 2
R817
13
Foil side
99
14
A
1
B
C
D
E
TS-480HX/480SAT
F
G
H
I
N
14V
CN8
14AF
14AG
5V
14S
8C
GND
GND
Q7
+
C34
4
TH1
1
3
BLACK
E
L16
L15
Q3
E
W1
GND
B
C
C36
+
CN12
R50
B
C63
GND
+
L24
C
Q4
R49
C72
B1+
R60
R59
C8
C66
B1+
D3
R35
C39
R51
C75
L2
C17 R17
R12
C67
C40
L28
E
L1
D
C14
Q2
D2
R10 C10
C13
R15
G
R14
C53
RED
C68
Q1
E
E
+
+
C52
R58
L9
R33
C20
C27
R40
L21
C81
C49
C50
C60
L18
R81
+
+
R42
R90
L14
F4
5
CN9
2
FAN1–
FAN1+
1
R34
R52
C70
R53
C69
R54
B
R63
C
Q5
FAN2+
1
C54
R80
C80
L5
VR2
L12
C71
R43
L17
R13
1 DOUT2
R41
R62
CN10
2
FAN2–
GND
GND
DIN2 5
7
C76
GND
BIN
E
R36
C18
E
4 DOUT1
GND
+
L20
CN4
DIN1 1
C22
R61
L27
L7
CN3
6
1
D5
8
R29
R7
G
S
D
TS-480HX/480SAT
CN7
R28
R9
S
2
VR3
C4
VR1
R
C56
5
Q6
+
CN6
Q
R39
R38
L13
C37
C42
O
+
CN1
DRV
P
R37
IC2
I
O
I
C47
R3
L3
R5
O
1
8
G
IC1
R24
CN13
R2
R16
M
200W FINAL UNIT (X45-366X-XX) (A/3)
0-00 : KH 2-71 : EH
Component side view (J72-0876-09)
R21
4
L
PC BOARD
G
R22
R23
14AT 1
CN5
R18
R20
GND 2
GND 18 R26
FANH
FANL
IC1+
IC1–
TH1
R25
PCS1
NC
NC R11
NC
VDT2 R66
ODP
TXB
TH2
R6
IC2–
IC2+
R4
PCS2
NC 1 R1
CN2
3
K
PC BOARD
200W FINAL UNIT (X45-366X-XX) (A/3) 0-00 : KH 2-71 : EH
Component side view (J72-0876-09)
2
J
C41
E
E
+
R32
L818
Ref. No. Address
IC1
2F
IC2
2G
IC3
13D
Q1
4E
Q2
4D
Q3
4F
Q4
4J
Q5
6J
Q6
2I
Q7
2I
Q803 13C
Q804
9G
Q805 12G
Q806 13E
D2
4F
D3
4J
D5
3M
D802 13C
D803 12G
D806
13I
D807 10C
4
5
6
7
8
8
C801
R816
R805
9
VR802
C841
L805
L823
D807
C832
R826
C831
R825
C830
R824
C
R838
R837
R811
10
L820
R836
L822
L809
E
E
9
C819
E
Q804
B
C829
C842
C843
10
E
C808
L802
GND
PO
R809
L810
C800
C811
C812
C823
R810
11
L821
C835
R827
C834
R828
C833
R829
Q805
B
C
R841
BLACK
E
1
IC3
GND
GND
B2+
B2+
+
Component side
Layer 1
Layer 2
R817
14
12
J72-0876-09 A/3
E
D806
G
CN829
RED
W801
C822
D803
R808
F801
+
C821
I
L807
5
4
Q806
8
E
O
D802
C809
C
E
L814
L806
+
C838
C807
+
B
Q803
E
R840
CN830
C836
R812
C828
+
C803
+
C816
R839
VR801
L804
12
13
L808
R800
L803
11
13
Foil side
14
A
1
B
C
D
TS-480HX/480SAT
E
F
G
H
I
J
PC BOARD
200W FINAL UNIT (X45-366X-XX) (A/3) 0-00 : KH 2-71 : EH
Foil side view
(J72-0876-09)
L26
2
C38
L25
L11
3
C31
TH1
C73
4
56
C51
C35
D4
C57
5
R55
Q9
C74
C65
C64
6
Q8
D6
C55
7
8
L8
10
11
C814
12
J72-0876-09 A/3
C817
L817
13
C837
L816
100
14
C23
TH2
9
J
K
L
M
N
O
PC BOARD
P
Q
R
S
TS-480HX/480SAT
1
200W FINAL UNIT (X45-366X-XX) (A/3) 0-00 : KH 2-71 : EH
Foil side view (J72-0876-09)
2
R19
C43
C46
C38
C32
C5
3
Ref. No. Address
C12
L19
C15
C44
C48
R56
Q8
Q9
6B
6B
Q807
D4
D6
13M
5C
6C
4
C29
C21
L6
R55
5
R67
C61
C62
C74
C79
6
C11
7
8
R821
R803
9
10
C827
C805
11
R822
R823
R804
12
C806
C826
C824
C810
C804
R814
R813
Q807
Component side
Layer 1
Layer 2
13
Foil side
101
14
A
1
B
C
D
TS-480HX/480SAT
E
F
G
H
I
J
K
L
M
N
PC BOARD
PC BOARD
P
Q
R
S
TS-480HX/480SAT
1
200W FINAL UNIT (X45-366X-XX) (A/3) 0-00 : KH 2-71 : EH
Foil side view (J72-0876-09)
200W FINAL UNIT (X45-366X-XX) (A/3) 0-00 : KH 2-71 : EH
Foil side view
(J72-0876-09)
2
L26
2
O
R19
C43
C46
C38
L25
C32
C5
3
L11
3
C31
TH1
Ref. No. Address
Q8
6B
Q9
6B
Q807 13M
D4
5C
D6
6C
C12
L19
C73
C15
C44
C48
4
R56
C51
C29
C21
C35
D4
C57
5
4
L6
R55
5
R67
Q9
C61
C62
C74
C65
C64
6
C79
6
Q8
D6
C55
C11
7
7
8
8
L8
C23
TH2
9
R821
R803
9
10
10
C827
C805
11
11
R822
R823
R804
C814
12
12
C806
C826
J72-0876-09 A/3
C817
C837
C824
C810
C804
L817
13
R814
R813
L816
14
Q807
Component side
Layer 1
Layer 2
13
Foil side
14
A
B
C
TS-480HX/480SAT
D
E
SCHEMATIC DIAGRAM
FINAL UNIT (X45-366X-XX)(A/3)[200W] 0-00:TS-480HX(K) 2-71:TS-480HX(E)
CN8
E40-3252-05
1
2
14AG
3
14S
4
5V
5
8C
6
14V
L13
14S
10u
FANH
FANL
IC1+
IC1PCS1
FANH
FANL
IC1+
IC1PCS1
TH2
CN6
2
13.25V
BIN
10u25
C22
C18
C11
L5
0.1u
VR2
220
C46
3
0.1u
C42
10u25
C38
0.1u
C47
C43
0.1u
3
F3
DIN1
R17
C13
18
0.1u
R14
C14
22
0.1u
Q2
2SK2595
R67
330
680
R16
R15
L1
47u
10
R12
R9
330
R7
680
R5
330
R2
330
T:0.93V
L6
1000p
VR1
220
C15
0.1u
C8
L2
10u
0.1u
C12
C5
0.1u
C21
0.1u
C20
470u265
PRE-DRIVE AMP
L3
TXB
DIN2
C79
C4
0.1u
CN1
R3
T:13.21V
470
T:1.36V
2.2 1/4W
T:2.36V
1u
C17
0.1u
Q1
2SK2596
L7
L39-1483-05
C10
0.1u
T:12.75V
PRE-DRIVE AMP
RF UNIT
X44-327X-XX
CN1
13.25V
GND
CN7
R10
220
3
1
IN
OUT
82
1
R13
AVR
7.85V
IN
OUT
F4
1.2A
2
C32
GND
0.01u
14AT
EXT.AT
IC2
TA7808F
GND
10u25
157-153-53002
C37
C31
0.01u
TH1
R25
3.3k
2
0.1u
R26
5.6k
AVR
TH1
TXB
CN5
E40-3246-05
1
IC1
TA7805F
4.94V
L11
-t
2
TH1
L8
0.01u
R21
5.6k
8
C23
7
GND
R19
3.3k
GND
TH2
8C
TXB
8C
0.1u
14AF
TH2
TX-RX UNIT
X57-663X-XX(A/2)
CN369
14V
C34
330u25
1
4
L805
R805
1.0 1W
C830
R22
100 1W
R23
1k
R821
IC1-
14 T:13.25V
47
R24
TH1
13 T:2.54V
L39-1450-05
4.7
L804
R823
10
R822
56p
C801
IC2-
R6
47
R4
IC2+
2
R1
47
PCS2
1
47
BIAS CONTROL
T:0.71V
T:7.93V
Q803
2SC3421(Y)
T:1.41V
CN830
R804
VR801
3.3k
L807
D802
CN829
4.7u
0.1u
390
1/8W
C806
TXB
MA27-B
D802,803
MA27-B
NC
T:13.86V
D803
PCS2
T:13.86V
0.1u
3
TXB
TH2
C810
4
T:2.56V
ODP
C807
10u25
IC2IC2+
0
3300p
R808
1.0 1W
L806
C804
0.1u
5
R66
3300p
C835
L821
TH2
47
T:7.13V
0.22u50
6
330u
VDT2
R11
C828
7
TXB
T:13.82V
3300p
C834
C803
10u25
ODP
L823
3p
8
D807
1SS348
18p
VDT2
47
C841
9
L802
L39-0477-05
HIGH-FREQUENCY
RECTIFICATION
C842
NC
3300p
C833
R18
330u
10
C836
0.01u
C809
L822
11
NC
0.01u
47
2200p
NC
100 1W
C843
TX-RX UNIT
X57-663X-XX(A/2)
CN359
6
12
3300p
C829
R800
1k
15 T:13.25V
100 1W
16
IC1+
L803
L39-1487-05
C805
560p
FANL
PCS1
3300p
C808
R803
R20
VR802
47k
5
17
C827
FANH
3300p
C832
0.01u
GND
FANH
FANL
IC1+
IC1TH1
PCS1
TH2
TXB
3300p
C831
CN2
E40-5978-05
18
TEMPERATURE
COMPENSATION
PCS2
VDT2
IC2IC2+
7
102
X45-366 (A/3) 1/3
PCS2
VDT2
IC2IC2+
F
G
H
I
J
TS-480HX/480SAT
SCHEMATIC DIAGRAM
FINAL UNIT (X45-366X-XX) (A/3)
14V
14V
14S
FANH
FANL
IC1+
IC1PCS1
14S
FANH
FANL
IC1+
IC1PCS1
TH2
8C
TXB
BIAS CONTROL
T:0.71V
C48
0.1u
C39
0.1u
C36
10u25
SUB UNIT (X58-4900-00)
BIN
T:7.81V
Q3
2SC3421(Y)
R6
330 1/4W
C2
T:1.40V
C62
CN13
L19
L28
1000p
330
1/4
0.01u
0.1u
13.28V
0.1 2W
C61
R5
C44
C6
Q2
2SK3075-H
C3
MA27-B
C4
22p
R3
3.3k
0.01V
DRIVE AMP
0.1u
D3
L15
L39-1450-05
R80
100 2W
C80
1
330p
1
2
C27
R8
VOLTAGE
SHIFT
C7
D2
DIN2
GND
DOUT2
TEMPERATURE
COMPENSATION
330p
5
GND
MA27-B
D2,3
L12
L39-1482-15
22u25
R90
1000p
3
22p
R9
GND
56
BIN
4
R10
3
0.1u
C1
R4
DIN2
GND
VR3
3.3k
L27
L39-1485-05
CN4
E40-5607-05
4
DOUT1
D2
CN12
390
1/8W
0.01V
3.3k
2
VOLTAGE
SHIFT
C10
C5
DIN1
D1
1
1
56
CN3
E40-5608-05
1SS388
DIN1
1SS388
R7
R28
Q1
2SK3075-H
330p
DRIVE AMP
4.7u
13.28V
0.1u
L16
R29
1.0 1W
C40
L9
C29
0.1u
3300p
C66
3300p
C67
3300p
C68
L14
L39-1487-05
0.01u
560p
100 1W
C35
R81
3300p
C72
C76
0.01u
C41
3300p
C69
FINAL AMP
4.7
10
R56
R55
C74
82
3300p
C70
3300p
C71
0.22u50
T:0.68V
3300p
R32
Q804
2SC2782
1.0M 1W
L17
10W
R816
330p
390p
C823
C800
TH2
100
330p
FINAL AMP
157-153-53002
390p
C812
10
1/4W
C811
R811
Q805
2SC2782
PO
L820
L39-1478-05
1
L818
2
T:13.84V
3
L39-1479-05
2
IC3
TA7808F
OUT
IN
SWITCHING
Q806
SI7445DP
T:13.81V
1
T:4.37V
T:13.82V
R813
0.1u
C838
10u25
C826
0.1u
C824
GND
3
R814
AVR
4
22k
C819
0
L809
0
R841
0
R840
R839
82
SWITCHING
10k
R843
56p
1
T:0.68V
C840
1
R829
L810
L39-1490-05
-t
1
R828
10
1/4W
R827
R812
1
0.01u
1/2W
1
R826
L39-1451-05
1/2W
R810
8.2
L808
R809
8.2
1
R825
0.01u
C839
R842
R824
0.01u
C75
0
0
R838
0
R837
R836
T:13.84V
T:0V
Q807
DTC114EKA
T:3.25V
PCS2
VDT2
IC2IC2+
PCS2
VDT2
IC2IC2+
103
X45-366 (A/3) 2/3, X58-490 1/1
K
L
M
TS-480HX/480SAT
N
O
SCHEMATIC DIAGRAM
FINAL UNIT (X45-366X-XX) (A/3)
14V
14V
14S
FANH
FANL
IC1+
IC1PCS1
14S
FANH
FANL
SURGE
ABSORPTION
CN9
E40-3246-05
C57
FAN1-
0.1u
D4
1SS355
2
FAN
1
FAN1+
0V
CN10
E40-3246-05
SWITCHING
Q7
DTC114EKA
0V
Q8
2SD1757K
0V
C54
Q9
2SD1757K
1
L26
L25
L24
L33-0617-15
0
0
R60
0
R59
R58
T:13.22V
0.01u
C65
C64
0.01u
22k
T:13.22V
T:13.21V
R38
T:4.15V
Q6
SI7445DP
W1
SURGE
ABSORPTION
R39
B1+
DC13.8V
Q4
2SC2782
330p
330p
390p
C50
C60
C81
GND
390p
10
1/4W
GND
C49
R35
R36
R52
10
1/4W
L39-1451-05
1
T:0.67V
1
R53
0.1u
B1+
C73
D5
470p
C56
C63
470u25
0.1u
C53
C52
100u25
C51
L20
C77
0.01u
T:0.67V
1
R51
8.2
1/2W
8.2
1/2W
R34
L18
R33
1
R50
FINAL AMP
0.1u
0.01 10W
82
ZSH5MA27
R64
R49
FAN
FAN2+
SURGE
ABSORPTION
470u25
SWITCHING
FAN2-
C55
0.1u
D6
1SS355
R43
12.95V
SWITCHING
SWITCHING
47 1/4W
R42
12.95V
47 1/4W
R41
47 1/2W
10k
R40
47 1/2W
2
R37
3.25V
L21
L39-1490-05
FINAL AMP
C78
1
Q5
2SC2782
0.01u
1
R54
R65
0
0
R63
0
R62
R61
82
FINAL UNIT (FILTER)
X45-366X-XX(B/3)[200W]
W101
T:13.22V
PO
PO
GND
L814
L33-0617-15
W801
R817
C837
DC13.8V
B2+
0.1u
ZSH5MA27
D806
470p
C822
470u25
C817
0.1u
C816
100u25
C814
0.1u
C821
B2+
0.01
10W
GND
GND
L817
L816
SURGE
ABSORPTION
F801
VDT2
IC2IC2+
VDT2
IC2IC2+
104
X45-366 (A/3) 3/3
5A
FINAL UNIT (X45-366X-XX)(A/3)[200W] 0-00:TS-480HX(K) 2-71:TS-480HX(E)
CN8
E40-3252-05
1
T:13.22V
MA27-B
T:13.21V
C65
C57
C55
0.1u
D6
1SS355
470u25
C54
0.01u
C64
0.01u
R38
CN13
L19
4.7u
C44
0.1u
T:4.15V
Q6
SI7445DP
T:13.22V
L24
L33-0617-15
0
0
R60
R58
R29
1.0 1W
C40
B1+
1
R54
1
330p
330p
390p
C50
C60
C81
C73
0.1u
D5
470p
C56
C63
470u25
0.1u
C53
C52
100u25
C51
0.1u
Q5
2SC2782
R65
3300p
R32
0
0
R63
0
R62
R61
82
FINAL UNIT (FILTER)
X45-366X-XX(B/3)[200W]
W101
10W
TH2
PO
R816
390p
C800
390p
10
1/4W
C78
3300p
C70
3300p
C71
PO
PO
L820
L39-1478-05
100
330p
C823
C49
L21
L39-1490-05
T:13.22V
157-153-53002
330p
C812
FINAL AMP
L20
C77
0.01u
R35
R36
8.2
1/2W
L39-1451-05
R33
R34
T:0.67V
1
R53
0.01u
4.7
0.22u50
10
R56
R55
C74
C839
0.01u
0.01u
C75
0
0
R838
390p
C811
GND
1
L818
2
T:13.84V
3
L39-1479-05
0
L809
R839
C819
82
4
56p
R843
0
R841
R800
100 1W
C805
560p
0
R837
R836
R810
8.2
1
GND
L810
L39-1490-05
T:0.68V
Q805
2SC2782
GND
L821
0.22u50
L39-1450-05
4.7
L804
R823
C828
3300p
C835
R52
L814
L33-0617-15
TH2
W801
R817
CN830
R804
390
1/8W
VR801
3.3k
L807
D802
D802,803
SWITCHING
L817
T:0V
T:3.25V
PCS2
VDT2
IC2IC2+
C837
0.1u
ZSH5MA27
D806
GND
Q807
DTC114EKA
PCS2
VDT2
IC2IC2+
470p
C822
470u25
C817
0.1u
C816
100u25
C814
0.1u
SURGE
ABSORPTION
TEMPERATURE
COMPENSATION
PCS2
VDT2
IC2IC2+
DC13.8V
B2+
GND
R813
0.1u
C838
10u25
C826
0.1u
CN829
4.7u
MA27-B
22k
T:4.37V
T:13.82V
L816
T:1.41V
TXB
1
GND
3
0.01
10W
R814
IN
SWITCHING
Q806
SI7445DP
T:13.81V
10k
OUT
PCS2
C824
47
IC3
TA7808F
MA27-B
47
2
D803
R1
1
Q803
2SC3421(Y)
0.1u
2
NC
IC2+
C810
PCS2
R4
T:7.93V
C807
10u25
47
AVR
BIAS CONTROL
T:0.71V
C821
B2+
IC2-
R6
0.1u
T:13.86V
1
R828
1
R829
1.0 1W
L806
C806
3
T:13.86V
TXB
R827
3300p
C834
3300p
R808
C804
0.1u
IC2+
4
0
T:2.56V
ODP
C803
10u25
IC2-
T:7.13V
10
5
R66
R822
6
TH2
47
C827
TXB
C841
7
330u
VDT2
R11
330u
ODP
T:13.82V
L822
8
2200p
VDT2
L823
C843
9
D807
1SS348
VR802
47k
10
L802
L39-0477-05
HIGH-FREQUENCY
RECTIFICATION
0.01u
47
56p
11
C801
NC
3300p
C833
3p
R18
18p
12
NC
C836
0.01u
C809
C842
PCS1
NC
100 1W
47
0
R840
R24
R811
47
13 T:2.54V
1
10
1/4W
14 T:13.25V
TH1
0.01u
R812
IC1-
3300p
C829
DC13.8V
B1+
Q4
2SC2782
1.0M 1W
L17
10
1/4W
R821
FINAL AMP
FINAL AMP
Q804
2SC2782
C840
1k
FINAL AMP
0.01u
R23
1/2W
15 T:13.25V
L803
L39-1487-05
1
R826
T:0.68V
L39-1451-05
IC1+
R803
3300p
C808
R809
8.2
100 1W
1
R825
L808
R22
3300p
C832
1/2W
FANH
FANL
IC1+
IC1TH1
PCS1
TH2
TXB
1k
R824
82
-t
TX-RX UNIT
X57-663X-XX(A/2)
CN359
R20
16
L18
560p
R81
100 1W
C35
C76
T:0.67V
1
3300p
C69
R842
3300p
C831
17
1
R51
0.01u
T:13.84V
1.0 1W
C830
FANL
3300p
C68
0.01u
C41
R805
FANH
1
R50
3300p
C72
L805
CN2
E40-5978-05
18
3300p
C67
8.2
1/2W
C29
L14
L39-1487-05
82
R49
10
1/4W
3300p
C66
0.1u
C8
0.1u
10u
W1
SURGE
ABSORPTION
R39
R64
ZSH5MA27
L9
0
R59
L16
L2
Q9
2SD1757K
SURGE
ABSORPTION
0.01 10W
GND
0.1u
D4
1SS355
R43
47 1/4W
R42
47 1/4W
R41
47 1/2W
R40
47 1/2W
10k
R37
C48
0.1u
C39
0.1u
D3
L15
0V
FAN
FAN2+
L26
330
1/4
Q8
2SD1757K
FAN21
L28
0.1u
13.28V
1000p
R5
C62
Q2
2SK3075-H
C3
0.01u
DRIVE AMP
0.1 2W
C61
0.01V
0V
SWITCHING
SWITCHING
L25
VOLTAGE
SHIFT
1
L39-1450-05
1
R80
C6
330p
DOUT2
1000p
100 2W
R3
D1
R9
2
TEMPERATURE
COMPENSATION
L6
C21
0.1u
C20
470u265
GND
MA27-B
D2,3
L12
L39-1482-15
1000p
VR1
220
C15
0.1u
C12
C5
0.1u
3
C80
R67
330
680
R16
R15
L1
47u
10
R12
R9
330
R7
680
R5
330
R2
330
PRE-DRIVE AMP
L3
R8
GND
330p
Q2
2SK2595
T:0.93V
TXB
DIN2
DOUT1
VR3
3.3k
L27
L39-1485-05
CN4
E40-5607-05
4
0.01V
C27
0.1u
GND
5
D2
C14
22
C79
R14
4
0.1u
C4
0.1u
DIN2
2.2 1/4W
R3
18
T:1.36V
F4
1.2A
CN1
1u
DIN2
390
1/8W
0.1u
C1
BIN
C17
0.1u
T:2.36V
T:13.21V
470
Q1
2SK3075-H
22u25
R90
R17
C13
Q1
2SK2596
VOLTAGE
SHIFT
C10
R4
T:12.75V
PRE-DRIVE AMP
GND
1SS388
DIN1
56
1
1
3
L7
L39-1483-05
C10
0.1u
12.95V
SWITCHING
D2
CN12
R28
56
DIN1
CN3
E40-5608-05
R10
DIN1
12.95V
13.28V
DRIVE AMP
F3
FAN
FAN1+
2
T:1.40V
CN7
R10
220
Q7
DTC114EKA
R6
330 1/4W
C2
0.1u
2
RF UNIT
X44-327X-XX
CN1
C36
10u25
BIN
C7
BIN
10u25
C22
C11
SUB UNIT (X58-4900-00)
L5
0.1u
VR2
220
C46
3
FAN11
CN10
E40-3246-05
SWITCHING
3.25V
0.1u
C42
10u25
C38
0.1u
3
2
T:7.81V
Q3
2SC3421(Y)
82
R13
13.25V
GND
C47
C43
0.1u
IN
OUT
1SS388
C32
GND
CN6
13.25V
1
CN9
E40-3246-05
0V
R7
2
0.01u
14AT
EXT.AT
2
SURGE
ABSORPTION
BIAS CONTROL
T:0.71V
C18
TH1
TXB
CN5
E40-3246-05
1
IN
OUT
1
GND
10u25
157-153-53002
C37
C31
0.01u
TH1
2
IC2
TA7808F
AVR
7.85V
0.1u
R26
R25
R19
3.3k
5.6k
L11
L8
IC1
TA7805F
AVR
4.94V
-t
TH2
8
TH1
3.3k
GND
8C
0.01u
7
R21
5.6k
GND
C23
6
TH2
8C
TXB
14S
FANH
FANL
22k
FANH
FANL
IC1+
IC1PCS1
TH2
8C
TH2
8C
TXB
14V
330p
5
10u
C4
5V
14S
FANH
FANL
IC1+
IC1PCS1
22p
4
14V
14S
FANH
FANL
IC1+
IC1PCS1
C5
14S
14V
14S
FANH
FANL
IC1+
IC1PCS1
22p
3
14V
14S
FANH
FANL
IC1+
IC1PCS1
3.3k
14AG
14V
L13
3.3k
2
0.1u
14AF
C34
330u25
TX-RX UNIT
X57-663X-XX(A/2)
CN369
14V
F801
PCS2
VDT2
IC2IC2+
VDT2
IC2IC2+
VDT2
IC2IC2+
5A
P
Q
R
S
T
TS-480HX/480SAT
SCHEMATIC DIAGRAM
1
K102
POUT
Land & Wire
C108
1000p
68p
C107 120p
820p
C104
1000p
560p
C105
L101
47u
C103
C106
C102
0
68p
D101
1SS355
C111
0.01u
GND
Land & Wire
GND
1.705~2.5
D101
GND
Land & Wire
GND
GND
Land & Wire
GND
GND
Land & Wire
GND
GND
Land & Wire
GND
SURGE ABSORPTION
L152
L39-1486-05
L153
L39-0458-05
C153
27p
L151
47u
680p
T68-2
C158 100p
150p
220p
D151
C159
C152
560p
C154
0
C155 1000p
T68-2
R151
K152
C156
K151
2
1SS355
C160
2.5~4.7
FINAL UNIT (ANT)
X45-366X-XX(C/3)[200W]
POUT
R101
GND
C109
PO
T68-2
L103
L39-1260-05
T68-2
L102
L39-1259-05
K101
W101
PIN
1000p
FINAL UNIT
X45-366X-XX(A/3)[200W]
FINAL UNIT (FILTER) (X45-366X-XX)(B/3) [200W] 0-00:TS-480HX(K) 2-71:TS-480HX(E)
0.01u
D151
SURGE ABSORPTION
K202
39p
18p
100p
C212
C214
56p
C209
C211
82p
C210 560p
C205
L201
47u
68p
C203 100p
L204
L39-1440-05
T68-6
T68-6
C208 68p
C207 470p
C202
0
C206
220p
R201
T68-6
C204 100p
L203
L39-1440-05
C213 330p
L202
L39-0463-05
K201
3
1SS355
D201
0.01u
C215
4.7~7.5
D201
SURGE ABSORPTION
9
8
0V
14M
7
13.13V
28M
6
0V
7M
5
0V
39p
270p
4
C308
22p
C259
180p
22p
C311
22p
R252
C313 100p
L301
47u
C307
C310
0
150p
R301
K302
T68-6
T68-6
C309
0V
L304
L39-1492-05
L303
L39-1492-05
L302
L34-1359-05
C306 120p
0V
3
0
SURGE ABSORPTION
C305 150p
4
R202
D251
47u
2M
0.01u
7.5~10.5
0V
21M
1
1SS355
D251
C261
K301
LED
K252
L251
4M
2
C255
0V
10M
GND
39p
C253
10
1SS355
D301
0
0.01u
C315
10.5~14.5
1.82V
D301
SURGE ABSORPTION
LED
C357
27p
C356
C461
C355
0
L351
47u
47p
56p
C360
10p
C359
C462
C358 220p
56p
R351
L354
L34-1279-05
L353
L34-1279-05
K352
C362 150p
L352
L34-1281-05
180p
K351
22p
D100
B30-2263-15
5
1SS355
D351
0.01u
C363
14.5~21.5
D351
SURGE ABSORPTION
C410
L401
47u
L405
18p
5p
C464 5p
C406
68p
K402
S76-0401-05
C412 82p
C403
C409 10p
L404
L34-1281-05
C408 180p
0
L403
L34-1281-05
C402 150p
R401
0
L402
L34-4661-05
C463
R402
39p
K401
S76-0401-05
D401
1SS355
C413
0.01u
6
21.5~30.0
D401
SURGE ABSORPTION
ADDITIONAL PCB
L455
49.0~54.0
C459 47p
6p
100p
C456
C457
27p
27p
C453
C455 15p
C451
L451
47u
0.01u
82p
0
K452
S76-0401-05
L454
L34-4662-05
L453
L34-4662-05
C454
R451
0
39p
R452
L452
L34-1359-05
C465
K451
S51-1420-05
C452
FINAL UNIT (ANT)
X45-366X-XX(C/3)[200W]
CN501
50M
T68-2
C257 33p
C254
68p
0
L253
L39-0460-05
T68-2
390p
R251
CN101
E40-5734-05
L252
L39-0463-05
C256
K251
D451
1SS355
C460
0.01u
D451
SURGE ABSORPTION
7
105
X45-366 (B/3) 1/1
A
1
B
C
D
E
TS-480HX/480SAT
F
G
H
I
J
PC BOARD
200W FINAL UNIT (X45-366X-XX) (B/3) 0-00 : KH 2-71 : EH
Component side view (J72-0876-09)
2
W101
PIN
C306
L303
C309
C310
K301
R201
J72-0876-09 B/3
C313
3
C305
L302
L304
L202
L203
K252
L354
L352
C358
L353
C362
6
K251
C356
C259
L253
K202
K201
L252
5
L204
K302
C255
4
K351
K352
L102
7
L103
K101
K102
C107
L405
R151
8
K401
L402
L403
L153
C158
D100
L455
K452
11
R101
Additional PCB
C156
10
K151
L152
K152
C402
C154
L404
C408
K402
9
LED
2M
GND
21M
7M
14M
10M
4M
28M
L452
50M
L453
L454
12
ADDITIONAL PCB
13
Foil side
106
14
Ref No. Address
D100
9J
K451
Component side
Layer 1
Layer 2
B
C
D
E
F
G
H
I
J
TS-480HX/480SAT
PC BOARD
1
200W FINAL UNIT (X45-366X-XX) (B/3) 0-00 : KH 2-71 : EH
Foil side view (J72-0876-09)
2
C307
C213
C212
C203
C214
C210
D301
C211
C202
C208
C209
C207
C206
C205
L201
J72-0876-09 B/3
C311
R202
L301
R252
C308
3
4
C315
C257
C256
5
C215
6
C360
C261
D251
C462
C461
R402
L351
C357
D201
C359
C254
C355
L251
C253
R452
C204
C363
C106
C105
C103
C104
C102
L101
R451
D351
C108
C109
D101
R301
D401
C413
9
C409
Additional PCB
10
C155
C152
C159
C153
C451
8
C412
R251
C111
C464
C463
R401
R351
L401
L151
L451
7
C403
C410
C406
C160
D151
W505
C465
C457
C456
C455
C454
C453
11
C459
1 LED
GND 2
21M
2M
7M
28M
14M
4M
9 10M
50M 10
C452
CN101
A
W504
W503
D451
C460
W502
W501
W506
12
ADDITIONAL PCB
Ref No. Address Ref No. Address
D101
8J
D301
4J
D151
D201
D251
10J
5J
6I
D351
D401
D451
7J
9J
12I
Component side
Layer 1
Layer 2
13
Foil side
107
14
A
1
B
C
D
E
TS-480HX/480SAT
F
G
H
I
J
PC BOARD
200W FINAL UNIT (X45-366X-XX) (C/3) 0-00 : KH 2-71 : EH
Component side view (J72-0876-09)
2
J72-0876-09 C/3
R505
BLACK
5 1
L505
K501
VSF
W503
W504
W505
Q504
R550
5 1
4 3
5 1
Component side
Ref No. Address Ref No. Address Ref No. Address
IC501
3H
Q504
4I
D505
4C
Q501
4H
Q505
3H
D506
3D
Q502
4H
Q506
3D
Q503
4I
D503
4D
6
4 3
1 50M
10M
4M
14M
28M
7M
2M
21M
GND
10 LED
W502
W501
5 1
CN501
L501
TC501
W506
Q503
Q502
L504
L502
C506
Q501
D505
C507
4 3
4
5 1
4 3
D503
C509
GND
5
C535
K502
L503
IC501
1
10
11
43
51
Q506
L507
ANT1
R507
Q505
4 3
C536
20
D506
GND
3
1 GND
TXB
VSR
VSF
GND
GND
GND
FEN2
CLK
DATA
14S
12 5C
R506
CN503
RAT
CN502
VSR
ANT2
Layer 1
Layer 2
Foil side
7
8
200W FINAL UNIT (X45-366X-XX) (C/3) 0-00 : KH 2-71 : EH
Foil side view (J72-0876-09)
J72-0876-09 C/3
D504
C511
C510
C505
L506
C512
R511
R509
9
C504
R553
R552
10
R503
R551
R504
D502
R510
C508
11
R508
D501
R501
C503
R502
C502
C501
12
Ref No. Address
D501 11E
D502 11E
D504 10G
13
108
14
Component side
Layer 1
Layer 2
Foil side
A
B
C
D
E
TS-480HX/480SAT
SCHEMATIC DIAGRAM
1
FINAL UNIT (ANT)(X45-366X-XX)(C/3)[200W] 0-00:TS-480HX(K) 2-71:TS-480HX(E)
C536
POUT
Land & Wire
8p
CN503
L507
RAT
K501
L502
POUT
R510 100k
R508 100k
1k
C508
1000p
R504
56p
C507
0.01u
27
GND
2
SURGE
ABSORPTION
0
R503
33
68p
D501,502
W505
0
ANT1
R509 100k
GND
R511 100k
D506
DSA301LA
47u
47u
L505
W506
0
L506
C502
HIGH-FREQUENCY
RECTIFICATION
0.01u
GND
Land & Wire
R553
GND
Land & Wire
GND
ANT2
D503,504
10
R501
W504
0
GND
D502
1SS348
D501
1SS348
R502
GND
C503
C501
C509
D505
DSA301LA
W503
0
1SS355
1SS355
GND
GND
Land & Wire
C512
D503
VSF
C510
L504
L40-1021-33
L501
47p
C511
3p
K502
S76-0424-05
0.01u
D504
GND
Land & Wire
C506
TC501
10p
W502
0
1000p
FINAL UNIT (FILTER)
X45-366X-XX(B/3)[200W]
GND
Land & Wire
GND
RF UNIT
X44-327X-XX
CN2
47p
150n -09
W501
0
D505,506
SURGE
ABSORPTION
3
VSR
Q501-505
DRIVER
Q505
FMA5A
13.08V
ATS’
DRIVER
13.09V
Q506
RN47A5
0.36V
R:0.10V
T:7.54V
R:0V
T:13.13V
0V
Q501
FMA5A
4
13.18V
ANT’
13.08V
50M’
13.14V
13.08V
0V
10M’
CN501
E40-5739-05
EXTENDED I/O
13.08V
IC501
BU2099FV
2M
7
21M
8
GND
9
LED
10
OE
DATA
SO
CLK
Q11
LCK
Q10
3
18
4
0V
Q503
FMA5A
13.08V
0V
Q9
Q1
Q8
Q2
Q3
ATS’
0V
Q504
FMA5A
10
13.08V
Q4
50M’
13.08V
28M’
13.08V
13
9
14M’
Q7
0.36V
0.37V
12
4M’
Q6
13.08V
13.08V
11
10M’
Q5
13.08V
CN502
E40-5758-05
13.08V
7M’
14
8
ANT’
13.08V
2M’
15
Q0
7
7M’
21M’
16
6
13.08V
1.82V
17
5
28M’
5
13.08V
2M’
0V
GND
1
TXB
2
TXB
VSR
3
VSR
VSF
4
VSF
GND
5
PHD
GND
6
AMD
GND
13.08V
GND
7
GND
R506
100
FEN2
8
FEN2
R505
100
CLK
9
CLK
R507
100
DATA 10
DATA
21M’
10u
L503
R550
390
14S
11
14S
5C
12
5C
TX-RX UNIT
X57-663X-XX (A/2)
CN375
6
19
NC
1.8k
7M
2
14M’
R551
5
VDD
C535
4
28M
20
VSS
0.37V
C504
14M
3.55V
1
13.13V
0.1u
FINAL UNIT (FILTER)
X45-366X-XX(B/3)[AT]
CN101
4M’
6
0.01u
3
Q502
FMA5A
4.7k
4M
0V
R552
2
C505
1
10M
1000p
50M
7
109
X45-366 (C/3) 1/1
A
1
B
C
D
TS-480HX/480SAT
E
F
G
H
I
J
PC BOARD
2
DISPLAY UNIT (X54-3410-00) (A/3, B/3, C/3) Component side view (J72-0877-09)
S33
PWR
D1
3
D16
D3
4
D10
LCD
S1
PF
5
D12
D17
S2
ATT
D18
6
S3
AT
D19
S4
CH1
S12
CH3
S8
CH2
D20
7
S16
DNL
D24
S20
MOD
D23
D26
S18
NR
S13
KEY
S9
MIC
S17
FIL
D25
S5
PWR
S21
MENU
8
S10
PRO
S6
NB
S19
BC
S14
VOX
D29
D27
D22
D21
S7
MET
S11
AGC
S24
FINE
S15
ENT
D28
9
10
B/3
VR1
MULTI ENC/IF SHIFT VR
(BLUE)
VR2
AF/SQl VR
(GREEN)
11
CN6
CN7
12
5V 1
5 GND
AFVL 4
SQVL
NC 2
1 5V
13
110
14
C/3
2 MUL2
MUL1
4 IFVL
GND 5
S23
SCAN
D30
J
K
L
M
N
O
P
Q
R
S
TS-480HX/480SAT
PC BOARD
1
2
DISPLAY UNIT (X54-3410-00) (A/3, B/3, C/3) Component side view (J72-0877-09)
S35
CLR
3
D13
D35
S34
RIT/XIT ENCODER
D11
S29
XIT
4
D4
D36
S30
RIT
D31
S31
UP
S32
DWN
D2
D14
D15
5
D32
6
S25
QMIN
S20
MODE
D33
7
D26
S26
QMR
J72-0877-09 A/3
S21
MENU
8
S27
A=B
D30
D34
S22
MHz
9
S28
A/B
10
Ref. No. Address Ref. No. Address Ref. No. Address Ref. No. Address
D1
D2
4B
5P
D14
D15
7L
7K
D22
D23
9E
7E
D30
D31
9J
5S
D3
D4
D10
4B
5P
5B
D16
D17
D18
4B
5B
6B
D24
D25
D26
7G
8H
7J
D32
D33
D34
5Q
7P
9P
D11
D12
D13
4P
5B
4P
D19
D20
D21
7A
7D
9D
D27
D28
D29
9G
9H
9I
D35
D36
3Q
4Q
Component side
Layer 1
Layer 2
11
Foil side
12
13
111
14
A
1
B
C
D
TS-480HX/480SAT
E
F
G
H
I
J
K
L
PC BOARD
M
N
O
P
Q
R
S
TS-480HX/480SAT
PC BOARD
1
2
2
DISPLAY UNIT (X54-3410-00) (A/3, B/3, C/3) Component side view (J72-0877-09)
DISPLAY UNIT (X54-3410-00) (A/3, B/3, C/3) Component side view (J72-0877-09)
S35
CLR
3
D13
D35
D1
S33
PWR
3
S34
RIT/XIT ENCODER
S29
XIT
D16
D3
D11
4
4
D36
D4
D10
LCD
S1
PF
S30
RIT
D31
5
D2
D12
D17
5
D32
S32
DWN
D18
D19
S4
CH1
S12
CH3
S8
CH2
D20
7
D15
S3
AT
S16
DNL
D24
S20
MODE
D14
6
S31
UP
S2
ATT
6
S25
QMIN
D33
D23
7
D26
S18
NR
S13
KEY
S9
MIC
S26
QMR
S17
FIL
D25
S5
PWR
J72-0877-09 A/3
S21
MENU
8
S10
PRO
S6
NB
8
S19
BC
S14
VOX
S27
A=B
D29
D30
D34
D27
D22
D21
9
S11
AGC
S24
FINE
S15
ENT
D28
S22
MHz
S7
MET
S23
SCAN
9
S28
A/B
10
10
B/3
11
VR1
MULTI ENC/IF SHIFT VR
(BLUE)
VR2
AF/SQl VR
(GREEN)
CN6
CN7
12
5V 1
5 GND
AFVL 4
SQVL
NC 2
1 5V
C/3
2 MUL2
MUL1
Ref. No. Address Ref. No. Address Ref. No. Address Ref. No. Address
D1
4B
D14
7L
D22
9E
D30
9J
D2
5P
D15
7K
D23
7E
D31
5S
D3
4B
D16
4B
D24
7G
D32
5Q
D4
5P
D17
5B
D25
8H
D33
7P
D10
5B
D18
6B
D26
7J
D34
9P
D11
4P
D19
7A
D27
9G
D35
3Q
D12
5B
D20
7D
D28
9H
D36
4Q
D13
4P
D21
9D
D29
9I
Component side
Layer 1
Layer 2
11
Foil side
12
4 IFVL
GND 5
13
13
14
14
A
1
B
C
D
E
TS-480HX/480SAT
F
G
H
I
J
PC BOARD
2
1
R20
R6
R2
R35
R34
R32
R31
R30
R36
R40
R39
50
51
76
75
C16
CP1
R19
R18
R16
C46
R55
R15
C45
R56
C32
L6
C33
6
R7
R63
L5
R8
R37
R12
C29
L7
Q6
IC3
CP3
3
5
Q5
CP4
C25
R59
Q1
CP2
5
R21
IC6
R47
J2
INTERNAL SP
100
CP5
L2
+
R48
1
C47
Q7
Q3
C17
R52
R29
R22
C41
C19
C21
Q2
R17
C42
C20
R28
R62
D37
R54
Q4
C22
25
26
C30
+
+
X1
1 5
IC4
3 4
C27
C31
C23
C26
C24
C18
4
1 5
IC5
3 4
R27
R33
C28
3
R26
R38
DISPLAY UNIT (X54-3410-00) (A/3, B/3, C/3) Foil side view (J72-0877-09)
7
1
SP
2
SPG
D9
D8
D7
D6
D5
CN2
L8
R23
J1
PHONE
L3
R25
R60
C34
8
R41
C35
1
R50
10
Component side
11
Foil side
12
13
112
14
Ref. No. Address Ref. No. Address Ref. No. Address
IC1
4P
Q2
4I
D6
7H
IC2
5M
Q3
4I
D7
7H
IC3
IC4
IC5
5G
3F
3F
Q4
Q5
Q6
3I
4I
5I
IC6
Q1
5E
4I
Q7
D5
5C
7H
D8
D9
D37
7H
7I
4D
GND
MEN2
R49
R42
MEN1
C36
5V
C37
R53
Layer 1
Layer 2
4
C43
R43
CN5
MUL2 2
MUL1
IFVL 4
5 GND
9
1 5V
CN3
R51
C44
9V
GND
J
K
L
M
N
O
P
PC BOARD
Q
R
S
TS-480HX/480SAT
1
2
3
C15 +
C6
R14
R13
C8
C7
R10
L1
C5
DISPLAY UNIT (X54-3410-00) (A/3, B/3, C/3) Foil side view (J72-0877-09)
32
R9
17
33
16
C9
R11
64
IC1
49
1
4
48
1
48
R1
32
C1
R3
33
16
17
64
49
IC2
C3
C4
R4
R5
5
C2
R57
6
R45
SQVL
AFVL 4
5 GND
C38
R44
7
NC 2
C39
R58
CN4
1 5V
8
GND
9
J72-0877-09 A/3
10
C/3
B/3
11
12
13
113
14
A
1
B
C
D
E
TS-480HX/480SAT
F
G
H
I
J
K
L
M
N
PC BOARD
O
P
PC BOARD
Q
R
S
TS-480HX/480SAT
1
2
2
Q6
R12
C29
L7
L5
R20
C5
C6
R7
R14
R13
C8
C7
R10
L1
R32
R31
R30
R21
R8
3
C15 +
32
R9
16
C9
R11
R6
64
R2
IC1
49
1
4
48
R35
1
48
R34
64
49
IC2
IC3
17
33
R36
33
16
R40
17
R1
32
C1
R39
50
51
76
75
R3
R37
C3
C4
R4
R5
5
C2
R57
R63
3
5
Q1
CP2
C25
R59
IC6
+
R47
C16
CP1
R19
R18
R16
R17
C46
R55
R15
C45
R56
C32
L6
C33
6
100
C17
1
5
Q7
J2
INTERNAL SP
1
C47
L2
R48
Q2
R22
R52
R29
Q3
CP4
C41
C19
C21
Q5
CP3
C42
C22
CP5
D37
R54
C20
R28
R62
C30
+
+
Q4
1 5
IC4
3 4
C27
DISPLAY UNIT (X54-3410-00) (A/3, B/3, C/3) Foil side view (J72-0877-09)
X1
25
26
C31
C23
C26
C24
C18
4
1 5
IC5
3 4
R27
R33
C28
3
R26
R38
DISPLAY UNIT (X54-3410-00) (A/3, B/3, C/3) Foil side view (J72-0877-09)
6
2
SPG
D9
D8
D7
CN4
L8
R23
J1
PHONE
R44
R25
R45
L3
7
1 5V
NC 2
SQVL
AFVL 4
5 GND
C38
SP
C39
1
R58
7
D6
D5
CN2
R60
C34
8
8
R41
C35
1
4
C43
R43
9V
GND
9
C44
R50
GND
R49
R42
MEN2
R53
MEN1
C36
5V
C37
CN5
MUL2 2
MUL1
IFVL 4
5 GND
9
1 5V
CN3
R51
J72-0877-09 A/3
10
10
Component side
11
Layer 1
Layer 2
Foil side
12
Ref. No. Address Ref. No. Address Ref. No. Address
IC1
4P
Q2
4I
D6
7H
IC2
5M
Q3
4I
D7
7H
IC3
5G
Q4
3I
D8
7H
IC4
3F
Q5
4I
D9
7I
IC5
3F
Q6
5I
D37
4D
IC6
5E
Q7
5C
Q1
4I
D5
7H
C/3
B/3
11
12
13
13
14
14
A
B
C
TS-480HX/480SAT
E
SCHEMATIC DIAGRAM
S34
S35
S36
S37
S38
S39
S40
S41
S42
S43
S44
S45
S46
S47
LCD DRIVER
IC1
32
31
30
29
28
27
26
25
24
23
22
21
20
19
18
17
S34
S35
S36
S37
S38
S39
S40
S41
S42
S43
S44
S45
S46
S47
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
S15
S14
S13
S12
S11
S10
S9
S8
S7
S6
S5
S4
S3
S2
S1
S16
S33
LCD DRIVER
IC2
LC75823W
S48
AS16
AS15
AS14
AS13
AS12
AS11
AS10
AS09
AS08
AS07
AS06
AS05
AS04
AS03
AS02
AS01
AS49
AS50
AS51
AS52
ACM1
ACM2
ACM3
BS49
BS50
BS51
BS52
BCM1
BCM2
BCM3
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
S48
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
AS33
AS34
AS35
AS36
AS37
AS38
AS39
AS40
AS41
AS42
AS43
AS44
AS45
AS46
AS47
AS48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
S49
S50
S51
S52
CoM1
CoM2
CoM3
VDD
INH 4.93V
VDD1 3.41V
VDD2 1.73V
VSS
OSC
CE
CL
DI
LC75823W
BS16
BS15
BS14
BS13
BS12
BS11
BS10
BS09
BS08
BS07
BS06
BS05
BS04
BS03
BS02
BS01
S32
S31
S30
S29
S28
S27
S26
S25
S24
S23
S22
S21
S20
S19
S18
S17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
S15
S14
S13
S12
S11
S10
S9
S8
S7
S6
S5
S4
S3
S2
S1
S16
S33
S49
S50
S51
S52
CoM1
CoM2
CoM3
VDD
INH 4.93V
VDD1 3.41V
VDD2 1.73V
VSS
OSC
CE
CL
DI
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
BS33
BS34
BS35
BS36
BS37
BS38
BS39
BS40
BS41
BS42
BS43
BS44
BS45
BS46
BS47
BS48
2
S32
S31
S30
S29
S28
S27
S26
S25
S24
S23
S22
S21
S20
S19
S18
S17
32
31
30
29
28
27
26
25
24
23
22
21
20
19
18
17
AS32
AS31
AS30
AS29
AS28
AS27
AS26
AS25
AS24
AS23
AS22
AS21
AS20
AS19
AS18
AS17
DISPLAY UNIT (X54-3410-00)(A/3)
BS32
BS31
BS30
BS29
BS28
BS27
BS26
BS25
BS24
BS23
BS22
BS21
BS20
BS19
BS18
BS17
R15
1k
R16
1k
R17
1k
R18
1k
R19
1k
L1
LDAT
LCS1
LCS2
10u
5V
47k
R14
C8
1000p
C7
0.01u
R13
C6
0.01u
0.1u
C15
C4
1000p
4.7k
C3
R57
47k
LCLK
R10
4.7k
R4
4.7k
0.01u
C2
C1
0.1u
LINH
R9
5.10V
10u10
C5
4.7k
4.7k
R5
R3
0.01u
R1
47k
3
4.7k
1
D
DIM0
DIM1
DIM2
DIM3
8M
D1-4,10-13
B30-2270-05
0.43V
0.06V
4
0.21V
0.06V
Q1
DTC114EE
R12
0.43V
5.01V
Q2
DTC114EE
D3
D10
D12
D2
D4
D11
D13
56
0.06V
Q3
DTC114EE
D1
56
0
R8
R7
0.43V
5.6
39
R6
120
R2
R11
CP5
47k
CP4
47k
Q4
DTC114EE
D1-4
D10-13
LED
LED
P50
TXD0
RXD0
S1-32,35
S70-0490-05
MODE
CLR
S20
S35
LINH
LCLK
LDAT
LCS1
LCS2
PWR
D5
S33
MA2S111
CH3
S8
S12
PWR
S1
S5
S16
MENU
QMIN
XIT
S21
S25
S29
MIC
KEY
FIL
MHz
QMR
RIT
S9
S13
S17
S22
S26
S30
D6
C9
C16
MA2S111
1000p
0.1u
D7
MA2S111
6
ATT
NB
PRO
VOX
NR
SCAN
A=B
UP
S2
S6
S10
S14
S18
S23
S27
S31
KOT4
KOT3
KOT2
KOT1
KOT0
CP1 10k
D8
MA2S111
AT
MET
AGC
ENT
BC
S3
S7
S11
S15
S19
FINE
S24
A/B
DWN
S28
S32
P40
P37
P36
P35
P34
P33
P32
P31
VCC
P30
VSS
P27
P26
P25
P24
P23
P22
P21
P20
P17
P16
P15
P14
P74
P75
TA3OUT
TA3IN
TA4OUT
TA4IN
INT0
INT1
INT2
P85
VCC
XIN
VSS
XOUT
RESET
P86
P87
CNVSS
BYTE
P90
P91
P92
P94
P93
47k
0
0
CP3
R20
R21
P41
P73
MCU
IC3
30622M8A-7N0GP
P13
CP2 10k
76
77
78
79
80
81
82
83
84
85
86
87
88
89
90
10k 91
92
93
0.1u 94
95
96
97
98
99
100
PF
CH2
S4
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
71
72
73
74
75
P12
P11
P10
P07
P06
P05
P04
P03
P02
P01
P00
P107
AN6
AN5
AN4
AN3
AN2
AN1
AVSS
AN0
VREF
AVCC
P97
P96
P95
REVERSE
CURRENT
PREVENTION
P42
P43
P44
P45
P46
P47
P50
P51
P52
P53
P54
P55
P56
P57
CTS0
P61
RXD0
TXD0
CTS0
P65
P66
P67
P70
P71
P72
50
49
48
47
46
45
44
43
42
41
40
39
38
37
36
35
34
33
32
31
30
29
28
27
26
D5-9
5
CH1
P70
P71
5.05V
Q1-4
SWITCHING
D9
7
114
X54-341 1/2
C17
IFVL
SQVL
AFVL
KIN2
KIN1
KIN0
KIN7
KIN6
KIN5
KIN4
KIN3
KIN7
KIN6
KIN5
KIN4
KIN3
KIN2
KIN1
KIN0
R22
MA2S111
25
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
P73
MUL2
PEN1
PEN2
MEN1
MEN2
MUL1
INT1
P85
VCC
XIN
VSS
XOUT
RESET
P86
P87
BYTE
DIM0
DIM1
DIM2
DIM3
P94
R32
47k
P95
F
G
H
I
J
TS-480HX/480SAT
SCHEMATIC DIAGRAM
DISPLAY UNIT (X54-3410-00) (A/3)
BS13
BS14
BS15
BS16
BS17
BS18
BS19
BS20
BS21
BS22
BS23
BS24
BS25
BS26
BS27
BS28
BS29
BS30
BS31
BS32
BS33
BS34
BS35
BS36
BS37
BS38
BS39
BS40
BS41
BS42
BS43
BS44
BS45
BS46
BS47
BS48
BS49
BS50
BS51
BS52
BCM1
BCM2
BCM3
AS01
AS02
AS03
AS04
AS05
1
AS24
AS23
AS22
AS21
AS20
AS19
AS18
AS17
AS16
AS15
AS14
AS13
AS12
AS11
AS10
AS09
AS08
AS07
AS06
AS45
AS44
AS43
AS42
AS41
AS40
AS39
AS38
AS37
AS36
AS35
AS34
AS33
AS32
AS31
AS30
AS29
AS28
AS27
AS26
AS25
BS12
BS11
BS10
BS09
BS08
BS07
BS06
BS05
BS04
BS03
BS02
BS01
ACM3
ACM2
ACM1
AS52
AS51
AS50
AS49
AS48
AS47
AS46
2
5V
3
1u
1u
1u
C45
C46
120
1u
R55
AND GATE
C33
120
C32
R56
1
3
11
10
2
4
5
6
8M
IC4
SWITCHING
INB
2
OUT
1 SP
C27
4.36V
4
C28
3
OUT
VSS
2
AVR
INA
1
3
1
J2
E58-0506-05
L8
SPG
8M
GND
RDO
TDO
SP
10u
L5
1u
L6
L7
C31
C30
0.01u
1u16
47u16
C25
D37
MA2S111
C26
0.01u
C24
0
1000p
R62
C23
0.1u
C20
C18
10u10
L2
10u
2
9.25V
VIN
5.51V
STB
AND GATE
P70
P71
5
R38
RXD0
5.05V
L78LR05B-FA
IC6
INB
GND
5.11V
Cn
5.11V
VOUT
VDD
4
5
10k
P50
TXD0
6
5
4
3
2
1
D37
R26
47k
C34
C29
D35
D31
D33
D27
D24
LED
D20
D16-36
B30-2269-05
R41
100
R42
100
R43
1k
D36
D32
D34
D28
D25
D21
D17
47k
47k
R51
R53
3.9k
R39
1.2k
680
R63
R40
D29
D30
180
330
R37
D26
180
R36
R35
D22
D23
1.5k
47k
47k
D18
R30
R31
D19
0.1u
0
R34
C19
R29
MUL1
IFVL
C22
22p
47k
X1
11.0592MHz
R28
C21
22p
P85
VCC
XIN
VSS
XOUT
RESET
P86
P87
1k
R58
R44
SQVL
BYTE
R45
AFVL
0.09V
5.01V
P95
2
2 MUL2
C36
1000p
3
3 MUL1
C37
1000p
4
4 IFVL
5
1k
Q6
DTC114EE
SWITCHING
PEN2
PEN1
R47
100
R48
100
C38
1000p
C39
1000p
1000p
C42
1000p
MEN2
R49
100
R50
100
C43
1000p
C44
1000p
1
3
4
6
5
R31-0645-05
CN7
E40-5409-05
1 5V
2 NC
3
3 SQVL
4
4 AFVL
5
5 GND
3
6
6
2
1 5 4
VR2
C41
5
2
5 GND
2
S34
W02-3662-05
5.10V
MEN1
J202
VR1
CN4
E40-5392-05
1
5.10V
0.09V
5.01V
SWITCHING
1000p
47k
47k
Q5
DTC114EE
1k
TX-RX UNIT
X57-663X-XX(A/2)
CN6
E40-5409-05
1 5V
C35
100k
R52
R54
P94
CN3
E40-5392-05
1
0.1u
MUL2
R27
1000p
5.10V
D16
R60
1k
SPG
8M
GND
RDO
TDO
SP
MULTI/IF SHIFT VR
X54-3410-00(C/3)
RESET CIRCUIT
P73
INT1
INT.SP
2 SPG
TC4S81F
4
1k
R59
IC5
C47
CN2
E40-3237-05
4
VSS
47k
R33
LED
BUSY
0.1u
B30-2167-05
220
D15
R25
R23
270
D14
B30-2276-05
LED
L3
PHONE
5.05V
VDD
INA
3
TX
TC4S81F
5
1
100p
5.10V
5.11V
100p
Q7
2SA1162(Y)
J1
E11-0482-05
R31-0644-05
AF/SQL VR
X54-3410-00(B/3)
4
5
3
2
1
CN5
E40-3239-05
1
5V
MEN1
2
MEN2
3
GND
4
MAIN
ENCODER
7
115
X54-341 2/2
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
S15
S14
S13
S12
S11
S10
S9
S8
S7
S6
S5
S4
S3
S2
S1
S16
S33
LCD DRIVER
IC2
LC75823W
S48
R15
1k
R16
1k
R17
1k
R18
1k
R19
1k
L1
LDAT
LCS1
LCS2
10u
5V
5V
INB
2
D7
MA2S111
ATT
NB
PRO
VOX
NR
SCAN
A=B
UP
S2
S6
S10
S14
S18
S23
S27
S31
KOT4
KOT3
KOT2
KOT1
KOT0
CP1 10k
D8
MA2S111
AT
MET
AGC
ENT
BC
S3
S7
S11
S15
S19
FINE
S24
A/B
DWN
S28
S32
CP2 10k
D9
GND
5.11V
Cn
5.11V
VOUT
3
5
100p
0.01u
1u
1u
C31
47u16
C25
C30
0.01u
C24
9.25V
VIN
5.51V
STB
1000p
C23
0.1u
C20
R20
R21
D35
D31
D33
D27
D24
D20
D16
0.1u
0
R30
R31
47k
47k
D36
D32
D34
D25
D28
47k
47k
C19
R29
D26
47k
D21
P42
P43
P44
P45
P46
P47
P50
P51
P52
P53
P54
P55
P56
P57
CTS0
P61
RXD0
TXD0
CTS0
P65
P66
P67
P70
P71
P72
P13
BYTE
DIM0
DIM1
DIM2
DIM3
1k
R51
R53
S30
100
R58
R44
SQVL
BYTE
R45
AFVL
0.09V
P94
P94
Q5
DTC114EE
5.01V
R32
47k
P95
1000p
2
2 MUL2
C36
1000p
3
3 MUL1
C37
1000p
4
4 IFVL
5
5 GND
Q6
DTC114EE
SWITCHING
PEN2
PEN1
R47
100
R48
100
C38
1000p
C39
1000p
C41
1000p
C42
1000p
100
R50
100
MEN2
C43
1000p
C44
1000p
R22
1
6
4
R31-0645-05
CN7
E40-5409-05
1 5V
2
2 NC
3
3 SQVL
4
4 AFVL
5
5 GND
S34
W02-3662-05
C17
R49
2
3
5
3
1 5 4
R31-0644-05
AF/SQL VR
X54-3410-00(B/3)
4
5
3
2
1
CN5
E40-3239-05
1
5V
MEN1
2
MEN2
3
GND
4
6
2
VR2
5.10V
IFVL
SQVL
AFVL
KIN2
KIN1
KIN0
KIN7
KIN6
KIN5
KIN4
KIN3
KIN7
KIN6
KIN5
KIN4
KIN3
KIN2
KIN1
KIN0
CN4
E40-5392-05
1
5.10V
MA2S111
MEN1
J202
VR1
0.09V
5.01V
SWITCHING
P95
1k
TX-RX UNIT
X57-663X-XX(A/2)
CN6
E40-5409-05
1 5V
C35
100k
1k
SPG
8M
GND
RDO
TDO
SP
MULTI/IF SHIFT VR
X54-3410-00(C/3)
CN3
E40-5392-05
1
47k
47k
S26
R42
R43
R52
R54
S22
IC3
30622M8A-7N0GP
R28
3.9k
S17
0.1u
P85
VCC
XIN
VSS
XOUT
RESET
P86
P87
R39
S13
1000p
100
MUL1
IFVL
1.2k
S9
MA2S111
1k
680
RIT
R27
R63
QMR
P85
VCC
XIN
VSS
XOUT
RESET
P86
P87
INT1
R40
MHz
MCU
R41
D29
FIL
C16
6
5
4
3
2
1
1000p
0.1u
D30
KEY
C9
C29
MUL2
180
MIC
D6
LED
D22
S29
L6
L7
5.10V
330
S5
S25
D16-36
B30-2269-05
180
S1
S21
MUL2
PEN1
PEN2
MEN1
MEN2
MUL1
INT1
D23
PWR
S16
10u
L5
C34
R35
S12
XIT
SPG
8M
GND
RDO
TDO
SP
RESET CIRCUIT
D17
S8
QMIN
47k
R60
1k
D18
S4
MENU
D37
MA2S111
J2
E58-0506-05
L8
P73
D19
CH3
76
77
78
79
80
81
82
83
84
85
86
87
88
89
90
10k 91
92
93
0.1u 94
95
96
97
98
99
100
PF
CH2
P73
1.5k
MA2S111
CH1
R26
25
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
R34
S33
P73
C22
22p
LCLK
LDAT
LCS1
LCS2
PWR
D5
P74
P75
TA3OUT
TA3IN
TA4OUT
TA4IN
INT0
INT1
INT2
P85
VCC
XIN
VSS
XOUT
RESET
P86
P87
CNVSS
BYTE
P90
P91
P92
P94
P93
P41
0
X1
11.0592MHz
S35
AND GATE
D37
C21
22p
CLR
S20
P40
P37
P36
P35
P34
P33
P32
P31
VCC
P30
VSS
P27
P26
P25
P24
P23
P22
P21
P20
P17
P16
P15
P14
10u10
C18
MODE
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
71
72
73
74
75
L78LR05B-FA
IC6
INB
4
VDD
0
0
47k
CP3
S1-32,35
S70-0490-05
LINH
AVR
1
5
R62
P12
P11
P10
P07
P06
P05
P04
P03
P02
P01
P00
P107
AN6
AN5
AN4
AN3
AN2
AN1
AVSS
AN0
VREF
AVCC
P97
P96
P95
REVERSE
CURRENT
PREVENTION
100p
1k
2
INA
L2
10u
50
49
48
47
46
45
44
43
42
41
40
39
38
37
36
35
34
33
32
31
30
29
28
27
26
D5-9
C27
R33
47k
3
VSS
2
P70
P71
TC4S81F
OUT
10k
P70
P71
INT.SP
2 SPG
1
RXD0
IC5
R38
RXD0
1 SP
1u16
P50
TXD0
OUT
4
5.05V
5.05V
Q1-4
SWITCHING
1u
4
VSS
PHONE
CN2
E40-3237-05
INA
C26
P50
TXD0
L3
J1
E11-0482-05
5.05V
VDD
4.36V
R59
LED
LED
BUSY
C47
D10-13
LED
B30-2167-05
CP4
47k
D1-4
220
56
0.06V
Q4
DTC114EE
TX
CP5
47k
D15
D13
D14
D11
B30-2276-05
5.01V
D4
0.1u
0
LED
D2
TC4S81F
5
1
C28
5.11V
3
R12
0.43V
Q3
DTC114EE
5.10V
R25
0.06V
Q2
DTC114EE
D12
R23
0.21V
D10
Q7
2SA1162(Y)
56
270
0.06V
Q1
DTC114EE
R8
R7
0.43V
5.6
39
R6
R2
120
0.43V
D3
IC4
SWITCHING
R37
D1
R11
1
3
11
10
2
4
5
6
8M
D1-4,10-13
B30-2270-05
R36
DIM0
DIM1
DIM2
DIM3
8M
C46
AND GATE
1u
120
C45
R55
1u
120
C33
R56
C32
47k
R14
C8
1000p
C7
0.01u
R13
4.7k
C6
0.01u
0.1u
C15
C4
1000p
4.7k
C3
R57
47k
R4
4.7k
0.01u
C2
C1
0.1u
LCLK
R10
4.7k
10u10
C5
4.7k
R5
4.7k
LINH
R9
5.10V
47k
R3
0.01u
R1
BS38
BS39
BS40
BS41
BS42
BS43
BS44
BS45
BS46
BS47
BS48
BS49
BS50
BS51
BS52
BCM1
BCM2
BCM3
AS01
AS02
AS03
AS04
AS05
AS16
AS15
AS14
AS13
AS12
AS11
AS10
AS09
AS08
AS07
AS06
AS05
AS04
AS03
AS02
AS01
AS49
AS50
AS51
AS52
ACM1
ACM2
ACM3
BS49
BS50
BS51
BS52
BCM1
BCM2
BCM3
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
S48
S34
S35
S36
S37
S38
S39
S40
S41
S42
S43
S44
S45
S46
S47
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
S49
S50
S51
S52
CoM1
CoM2
CoM3
VDD
INH 4.93V
VDD1 3.41V
VDD2 1.73V
VSS
OSC
CE
CL
DI
LC75823W
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
AS33
AS34
AS35
AS36
AS37
AS38
AS39
AS40
AS41
AS42
AS43
AS44
AS45
AS46
AS47
AS48
AS24
AS23
AS22
AS21
AS20
AS19
AS18
AS17
AS16
AS15
AS14
AS13
AS12
AS11
AS10
AS09
AS08
AS07
AS06
IC1
BS16
BS15
BS14
BS13
BS12
BS11
BS10
BS09
BS08
BS07
BS06
BS05
BS04
BS03
BS02
BS01
AS45
AS44
AS43
AS42
AS41
AS40
AS39
AS38
AS37
AS36
AS35
AS34
AS33
AS32
AS31
AS30
AS29
AS28
AS27
AS26
AS25
LCD DRIVER
BS13
BS14
BS15
BS16
BS17
BS18
BS19
BS20
BS21
BS22
BS23
BS24
BS25
BS26
BS27
BS28
BS29
BS30
BS31
BS32
BS33
BS34
BS35
BS36
BS37
AS32
AS31
AS30
AS29
AS28
AS27
AS26
AS25
AS24
AS23
AS22
AS21
AS20
AS19
AS18
AS17
32
31
30
29
28
27
26
25
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
S15
S14
S13
S12
S11
S10
S9
S8
S7
S6
S5
S4
S3
S2
S1
S16
S33
BS12
BS11
BS10
BS09
BS08
BS07
BS06
BS05
BS04
BS03
BS02
BS01
ACM3
ACM2
ACM1
AS52
AS51
AS50
AS49
AS48
AS47
AS46
S34
S35
S36
S37
S38
S39
S40
S41
S42
S43
S44
S45
S46
S47
S32
S31
S30
S29
S28
S27
S26
S25
S24
S23
S22
S21
S20
S19
S18
S17
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
BS33
BS34
BS35
BS36
BS37
BS38
BS39
BS40
BS41
BS42
BS43
BS44
BS45
BS46
BS47
BS48
S49
S50
S51
S52
CoM1
CoM2
CoM3
VDD
INH 4.93V
VDD1 3.41V
VDD2 1.73V
VSS
OSC
CE
CL
DI
S32
S31
S30
S29
S28
S27
S26
S25
S24
S23
S22
S21
S20
S19
S18
S17
32
31
30
29
28
27
26
25
24
23
22
21
20
19
18
17
BS32
BS31
BS30
BS29
BS28
BS27
BS26
BS25
BS24
BS23
BS22
BS21
BS20
BS19
BS18
BS17
DISPLAY UNIT (X54-3410-00)(A/3)
MAIN
ENCODER
A
1
B
C
D
E
TS-480HX/480SAT
F
G
H
I
J
PC BOARD
C469
CN555
C562 TH551 C561
C553
14
Q554
23
C576
7 NC MSG MCG MU 1
13
J351
MIC
116
43
Q807
R217
IC220
R218
R221
R223
CP222
R291
C306
IC222
IC223
15
C317 R312 C318
X202
20
36
37
D212
C243
1
R313
C
L217
+
C241
43
61
Q207
R260
C246
O
R252
5 1
R253
R256
C707
C706
IC695
4 3
G
C238
R331
1
14
CP232
C324
C242 +
IC219
3 4
C307
10
IC210
R265 C276
R330
11
C273
R264
109
108
73
1 5
C299
R296
CP230 CP226 CP223
R295
R231
1
R290
R262
CP2
144
1
Q204
C263
C297 C295
R258
16
C275
C285
51
Q732
1
CP210
R371
C283
D817
R271
CP214
C284
144
C298 C294
C259
8
9
1
8
IC218
4
5
5
CP212
51
+
I
5V
IC213
ANO
RT
AIN DTS
BR
5 8M RDO SP 1
6 SPG GND TDO 2
J202
PANEL
J731
EXT. SP
NC GND
GND
J132
DATA
14
C209
11
10
4
D735 Q733
43
C313
C291 R267
8
D202
+
R764
C705
C289
R279
R266
E
C
C214
8
IC202
IC731
20
C737
1
4
1
7
IC683
5
8
8
14
1
IC682
11
10
1
72
7
C301
R301
Q202
R303
Q201
B
8C 2
L972
C574
R593
SQC
8 MD MIC SS
C972
14
R556 C558
CN971
R626
D624
1
IC621
R635
R587
Q556
R563 R562
R2
Q1
R4
R11
R12
R26
C14
R624 C627
R14
C577
C588 C586
C604
R594
C589
1 8
IC553
4 5
C585
R584
D559
R588 R589
C587
R603
R259
IC217
L218
1
IC221
4
R298
5
C315
R310
1.6V
R300
K731
L223
R305
R293
C316 C305
D358
R972
Q551
41
R281
C265
1
R261
R289
R292
B
C414
R365
D356
1 RXOUT
L553
C300
R317
R294
+
8
5
C
C322
R307 C304
R364
FMIF
R574 R575
37
R278
C264
8
1
4
IC224
R316
E
R754
C744
5
24
IC214
IC212
4
1
12
13
1
C308
D355
CF551
455k
L554
C41
C281
C267
C311
C756
1
RXB
FMIF
32
IC205
20
1
C98
+
C282
14AF
+
9
+
11
12
FILT4
RXB
1 RXOUT
IC551
8
FILT3
FILT4
CP211
8
D357
FILT2
FILT3
SM
14AG
14V
FILT2
Q17
+
+
C29
7
R40
R41
R56
Q12
R770
R760
CN1
LO2
(WHITE)
+
C105
C101
C269
R87
8
C755
14S
C754
TXIN
FILT1
C566
R596 R592
Q558
1
TXIN
FILT1
C584 C582 R586
L33
+
CN369
IC734
5V
9
Q735
D555
FILT5
IFGC
8C
C758
C583
R583
15C
FILT5
AMB
GND
+
+
1
16
1
R552
GND
VR622
R647
L551
36
C752
10
C581
L556
C763
+
+
8
R33
C42
C50
R59
L466
R459 C471
C456
R456
R458
C594
C750
GND
R649
D625
15.6M
15C
R321
G
R625 C622
TH621
Q621
R658 and TH622
34
+
R627
12
GND
R622
R560
IC552
R272
8
4
R269
C751
5
8
7
14
R636
R270
I
R591
R638
VR621
L221
O
R55
R637
R570
IC733
C470
L222
13
IC216
+
C252
R60
C635 +
C602
C465
C287
I
G
R453
C462
+
C254
R471
C266 C253
O
AGC
8
C262
C487
R466
IC215
R463
C256
7
L458
C467
C464
D454
C474
R464
C482
R468
C468
R455
R457
C466
C460
Q452
D
G
S
L465
R470
C486
C455
C461
R454
C484
R469
D453
C463
C479
Q456
D
G
S
L457
D456
C459
Q451
D
G
S
Q8
C48
C476
R465
6
C634
C55
L14
12 15.6M
TC1
C633
L13
L463
L456
L464
C481 C485
C483 C488
C478
TC451
C49
R47
C477
TC453
TP
C64
R46
L455
D452
C472
TC452
L452
C452
L462
D455
C473
C453
5
C451
L453
D451
R452
L461
Q455
R460
L451
R850
C623
R641 C624
L9
R37
L19
C60
R61
R20
L31
C90
Q15
R91
R93
R85
C52
R92 C103
L454
R451
R104
1
L15
R54
C2
C8
L6
R23
R1
R5
R631
IC2
16
C9
C3
R644
C51
X1
C579
R36
R49
8
C628
C46
Q4
R17
C592
L30
R66
C84
R63
L26
L23
R89
R69
C96
Q5
Q6
9
Q10
61
R83
C80
Q18
43
R80
C94 +
R65
C22
R13
R22
R590
R90
+ C106
+ C99
R74
C73
R96
16
R79
IC3
9
CV
L35
1
C23
C21 +
C120
CN3
LO1
(BLUE)
R82
R95
C102
R71
4
R86
R81
R72
R76
C91
C97
C18
C32
1
8
Q14
R75
C100
R108
C119
R64
C89
16
R10
Q7
R31
IC1
R18
R24
C30
R34
C40
3
C121
C26
R43
R51
R28
R39
R42
D1
C63
8
C11
R25
L11
L7
9
R21
C25
R48
16
C54
C122
34
Q9
R109
C57
R103
R30
C35
C36
C124
L16
C61
L20
R52
C69
C65
CF1
C123
R45
J72-0878-19 A/2
2
Q11
R58
R57
TX-RX UNIT (X57-663X-XX) (A/2, B/2) 0-11 : KH 0-12 : KS 2-71 : EH 2-72 : ES
Component side view (J72-0878-19)
J
K
L
M
N
O
P
Q
R
S
TS-480HX/480SAT
PC BOARD
1
TX-RX UNIT (X57-663X-XX) (A/2, B/2) 0-11 : KH 0-12 : KS 2-71 : EH 2-72 : ES
Component side view (J72-0878-19)
5C
1
14S
DATA
CLK
FEN2
GND
AMD
PHD
VSF
VSR
TXB
GND 12
J72-0878-19 B/2
CN375
XF931
TCXO
OPTION
FIL1
C183
FIL2
FIL2
C184
BLNK
BLNK
FIL1
R919
R903 Q903
R926
VSR
RXB
IFGC
RXB
C901
C904
C902
L901
L902
TXB
C923
TXB
8C
8C
GND
GND
IFIN 10
W501
10 IFIN
R907
R906
L909
OPTION FILTER 1
AMD
AGC
IFGC
CN554
+
CN901
C973
1
AGC
R901
XF932
1
1 NB
2 GND
R911
C913
R706
4 3
IC684
C685
C682
R858
R808
VR2
C739
5
+
R748
J131
REMOTE
W501
C527
R772
C507
C203
NB
C526
L507
R142
C509
R209
+
D208
R522
R521
R210
RXD
TXD
NC
GND
J201
COM
NC
RTS
CTS
NC
R524
2 GND
3
4
5
6
7
8
9
10
11
12
Component side
C524
Q506
C522
D205
D207
NC
34
C204
Q502
16
L211
NB
2
R523
1
1
L506
R507
51
C140
GND
D683
C420
R747
8
IC732
4
C206
16
IC203
34
SS
R685
L363
R811
C205
C217 R326
8
C220
9
MKE ALC
SPO
43
51
Q681
C694 C696
D682
R696
C692
R683
C814
5
R810
R826
C386
L362
4
1 GND
KEY
DASH
DOT
KYS
AGC
CKYS
PGC
PRES
DATA
CLK
REN
3C
8C
14S
RXB
TXB
18 GND
+
Q203
43
BRK COM
R692
8
K131
RL
R693
IC801
B
RTK
C697
R695
CKY
C693
R689
D681
CKYS C687
C813
1
1
R742
CP221
CP802
R802
D806
D808
R817
R812
R743
R840
R746
L801
R319
C395 C393 C388
R332 R333
1 8
IC208
4 5
C732 R744
R774
R224
C236
C390
D816
L201
Q135
15
R138
C
C232
Q683
R830
R749
4 5
E
+
CP233
IC207
1 8
Q132
R342
CP225
CP228
C238
3 4
72
CP231
5 1
R235
CP224
73
CP232
IC211
4 3
X201
C227 C228
C240
CP219
IC204
IP4
NC 26
NC
IP3
NC
NC
NC
NC
5C
AI
C394
AGND
RST
VR1
EN
C391
SI
PLAY 2
C392
9
R700
D818
8
R834
CN390
25 NC
NC
NC
NC
NC
NC
AGND
AO
DGND
USEL
CLK
SO
1 BUSY
ALC
R841
7
5 4
IC225
8 1
Q806
14
IC802
C810
CP215
109
108
R320
8 1
IC209
8
+
R820
1
61
Q682
43
R824
R818
5 4
R847
C821 +
VSFM
R835
CP205
CP206
R833
CP207
IC681
ALM
R857
VR2
CP209
D807
R848 R859
CP210
R853
VSRM
CP213 CP204
16
1
C695
R202
CP208
RXB
TXB
R827
9
1
R809 R821
8
TT
VR1
5
CN382
IC201
+
TS
Q803
15
34
2
R201
S201
C209
16
34
GND 3
1
8
Q684
16
5 1
C703 R705
CN359
1 GND
FANH
FANL
IC1+
IC1–
TH1
PSC1
FEN1
DATA
CLK
VDT2
ODP
TXB
TH2
IC2–
IC2+
PSC2
18 ATEN
OPTION FILTER 2
CN403
L908
R923
CN501
IF
(RED)
C924 Q902
R920
C911
72
Ref. No. Address Ref. No. Address
Q201 12C
IC1
2E
Q202 12D
IC2
3E
Q203 12N
IC3
4A
Q204
11I
IC201
7K
Q207 12G
IC202
7J
6A
IC203 11N Q451
Q452
6C
IC204
9K
Q455
5D
IC205
7F
6B
IC207 11K Q456
IC208 10M Q502 11P
Q506 13O
IC209
8L
6I
IC210 11J Q551
Q554
6H
IC211 9M
Q556
5G
IC212
9D
Q558
6F
IC213
12I
Q621
3G
IC214
9E
Q681
9P
IC215
7C
Q682
7O
IC216
8C
8O
IC217 10E Q683
7O
IC218 11E Q684
8I
IC219 12E Q732
Q733
8I
IC220
9G
IC221 11D Q735 10B
8N
IC222 11H Q803
8O
IC223 11H Q806
8I
IC224 10D Q807
Q902
5N
IC225 9M
Q903
3N
IC551
5H
D1
3C
IC552
5F
D202 12D
IC553
6F
D205 12N
IC621
4G
D207 13N
IC681
7O
D208 13N
IC682
7G
D212
11I
IC683
7H
D355 12B
IC684
6P
D356 12B
IC695 12F
D357 12B
IC731
7I
IC732 10N D358 12C
D451
5A
IC733
6E
D452
5C
IC734
9A
D453
7A
IC801
9O
D454
7C
IC802
8N
D455
5B
Q1
2G
D456
7B
Q4
3G
D555
6F
Q5
3F
D559
5F
Q6
3E
D624
4G
Q7
3D
D625
3H
Q8
5F
D681
9P
Q9
2C
D682
9O
Q10
4D
D683
9P
Q11
2B
D735
8H
Q12
5F
D806
9N
Q14
3B
D807
8N
Q15
4C
D808
9N
Q17
7E
D816
9O
Q18
4B
8I
Q132 12K D817
8O
Q135 12K D818
NBL
Layer 1
Layer 2
Layer 3
Layer 4
13
Foil side
117
14
H
I
J
K
FMIF
14
J351
MIC
J202
PANEL
5C
1
14S
DATA
CLK
FEN2
GND
AMD
PHD
VSF
VSR
TXB
GND 12
61
Q682
C682
R858
AIN DTS
BRK COM
R810
R808
VR2
R746
C739
VR2
VR1
4
C420
+
GND
GND
J132
DATA
J131
REMOTE
CN359
1 GND
KEY
DASH
DOT
KYS
AGC
CKYS
PGC
PRES
DATA
CLK
REN
3C
8C
14S
RXB
TXB
18 GND
R747
8
IC732
5
R748
W501
C527
R772
R
S
1
C507
C509
NB
C526
R209
+
D205
D207
R522
R521
R210
NC
34
Q502
16
C204
RXD
TXD
NC
GND
J201
COM
NC
RTS
CTS
NC
2 GND
2
3
4
5
6
7
8
9
10
11
12
Component side
C524
R524
NB
Ref. No. Address Ref. No. Address
Q201 12C
IC1
2E
Q202 12D
IC2
3E
Q203 12N
IC3
4A
Q204
11I
IC201
7K
Q207 12G
IC202
7J
6A
IC203 11N Q451
Q452
6C
IC204
9K
Q455
5D
IC205
7F
6B
IC207 11K Q456
IC208 10M Q502 11P
Q506 13O
IC209
8L
6I
IC210 11J Q551
Q554
6H
IC211 9M
Q556
5G
IC212
9D
Q558
6F
IC213
12I
Q621
3G
IC214
9E
Q681
9P
IC215
7C
Q682
7O
IC216
8C
8O
IC217 10E Q683
7O
IC218 11E Q684
8I
IC219 12E Q732
Q733
8I
IC220
9G
IC221 11D Q735 10B
8N
IC222 11H Q803
8O
IC223 11H Q806
8I
IC224 10D Q807
Q902
5N
IC225 9M
Q903
3N
IC551
5H
D1
3C
IC552
5F
D202 12D
IC553
6F
D205 12N
IC621
4G
D207 13N
IC681
7O
D208 13N
IC682
7G
D212
11I
IC683
7H
D355 12B
IC684
6P
D356 12B
IC695 12F
D357 12B
IC731
7I
IC732 10N D358 12C
D451
5A
IC733
6E
D452
5C
IC734
9A
D453
7A
IC801
9O
D454
7C
IC802
8N
D455
5B
Q1
2G
D456
7B
Q4
3G
D555
6F
Q5
3F
D559
5F
Q6
3E
D624
4G
Q7
3D
D625
3H
Q8
5F
D681
9P
Q9
2C
D682
9O
Q10
4D
D683
9P
Q11
2B
D735
8H
Q12
5F
D806
9N
Q14
3B
D807
8N
Q15
4C
D808
9N
Q17
7E
D816
9O
Q18
4B
8I
Q132 12K D817
8O
Q135 12K D818
R523
L211
C206
1
1
L506
R507
51
SS
D683
L363
R811
C205
16
IC203
MKE ALC
SPO
R685
L362
5
Q506
RL
43
51
Q681
C694 C696
D682
R696
C692
R802
R820
R683
C814
C685
43
R835
R833
R827
R809 R821
R826
5 1
R847
D806
D808
R817
C810
R812
C386
8
1
R742
CP224
34
C695
L801
R319
8
D208
NC GND
9
Q203
43
RTK
R692
IC801
4
K131
ANO
R693
+
34
IC213
J731
EXT. SP
1
C697
R695
CKY
C693
R689
D681
CKYS C687
C813
B
I
5V
R840
L507
C
+
Q683
D816
L201
Q135
15
E
R700
D818
CP802
9
C203
G
R743
ALC
R830
R749
4 5
Q132
C732 R744
R774
C217 R326
O
C238
L217
+
C390
8
+
R841
R834
C220
61
Q207
R260
C246
R252
R256
R253
43
C241
IC695
4 3
CP233
IC207
1 8
R331
C324
C395 C393 C388
CP221
CP228
CP231
C232
CP225
CP232
R342
R332 R333
CP219
R313
3 4
IC210
C243
1
R235
R224
20
72
C236
34
IC223
15
X202
D212
1 5
IC222
C317 R312 C318
37
Q204
10
73
R231
C299
11
36
IC211
4 3
C240
1 8
IC208
4 5
IC204
R221
X201
C227 C228
R321
R218
Q806
8
IP4
NC 26
NC
IP3
NC
NC
NC
NC
5C
AI
C394
AGND
RST
VR1
EN
C391
SI
PLAY 2
C392
25 NC
NC
NC
NC
NC
NC
AGND
AO
DGND
USEL
CLK
SO
1 BUSY
16
IC681
ALM
R857
14
7
5 4
IC225
8 1
RXB
1
IC802
CN390
5 8M RDO SP 1
6 SPG GND TDO 2
8 1
IC209
109
108
144
1
1
CP215
Q807
R818
R371
D817
51
Q732
C306
C821 +
VSFM
5 4
CP214
43
109
108
CN382
S201
CP205
CP206
C703 R705
TXB
D807
R848 R859
CP207
R853
VSRM
CP213 CP204
R320
R764
CP209
1
R202
CP208
CP210
TT
R824
CP230 CP226 CP223
R265 C276
R330
9
+
TS
Q803
15
34
10
8
R223
73
1
14
IC219
R201
IC201
5
CP212
C242 +
8
C209
11
IC731
20
C737
1
4
1
1
7
IC683
5
8
8
14
IC682
C283
R296
C706
CN501
IF
(RED)
C924 Q902
R920
R911
14
Q554
23
L554
C604
R271
1
C273
C275
C285
1
IC218
8
5
C301
R301
D735 Q733
43
51
C284
IC220
5 1
CN554
R901
R907
L908
C588 C586
11
10
IC202
4
16
CP222
1
16
R292
4
1
R294
R293
5
Q202
D202
1
8
R217
C307
1 GND
FANH
FANL
IC1+
IC1–
TH1
PSC1
FEN1
DATA
CLK
VDT2
ODP
TXB
TH2
IC2–
IC2+
PSC2
18 ATEN
R706
GND 3
1
C140
13
2 GND
5 1
C313
C291 R267
E
C
C214
+
1 NB
IC684
R295
R264
W501
10 IFIN
C574
R290
R262
GND
OPTION FILTER 2
R291
R266
8C
GND
C576
C297 C295
C263
TXB
8C
IFIN 10
R923
L553
144
C298 C294
C259
R258
RXB
4 3
72
7
7 NC MSG MCG MU 1
L972
Q551
41
C289
R279
IFGC
C913
R593
VSR
C911
R972
R574 R575
IC205
R259
R289
R303
Q201
B
8C 2
C923
OPTION FILTER 1
AMD
AGC
IFGC
TXB
C972
CF551
455k
BLNK
RXB
1 RXOUT
SQC
8 MD MIC SS
R919
R903 Q903
CN555
C562 TH551 C561
C553
9
BLNK
AGC
C902
FMIF
C184
1
C901
C904
L902
RXB
32
C589
CN971
RXB
R563 R562
14
R644
R556 C558
R584
C577
FILT4
C566
1 8
IC553
4 5
C585
FILT4
1 RXOUT
IC551
8
FILT3
C584 C582 R586
R594
R603
16
1
R552
FILT2
FILT3
C183
FIL2
1
CN901
R2
Q1
R626
D624
1
7
IC621
R635
D559
R588 R589
R587
C41
R278
IC217
9
C322
IC221
C315
1.6V
R300
R310
R305
4
R298
L223
K731
R4
R11
R12
C14
R624 C627
R14
R26
8
L551
C300
R317
C316 C305
D358
FILT2
+
VR622
R647
R281
C265
1
8
8
1
8
5
B
C414
R365
D356
FILT1
XF932
C973
R649
37
R261
C264
L218
4
IC224
R316
+
R754
C744
5
24
IC214
IC212
4
1
12
E
C308
R364
C587
1
C281
R307 C304
D355
FILT1
TH621
Q621
R658 and TH622
C705
C282
13
1
C311
C756
1
R583
D555
20
C98
C101
+
C267
C
+
TXIN
R926
+
11
12
FILT5
TXIN
FIL1
FIL2
FIL1
CP211
8
D357
FILT5
SM
14AG
14V
15C
Q17
14AF
+
L556
Q556
R33
R40
R41
Q12
CN1
LO2
(WHITE)
R87
+
C105
+
Q735
C581
C583
1
C707
C754
GND
15C
C522
C469
R456
R770
R760
R459 C471
C456
C467
R458
+
8
C755
14S
GND
R622
D625
CN375
TCXO
OPTION
AMB
CN369
IC734
5V
12 15.6M
IFGC
8C
9
C758
1
L33
GND
C752
+
12 15.6M
R625 C622
36
GND
+
8
C763
+
10
R627
Q
TS-480HX/480SAT
J72-0878-19 B/2
TC1
R560
IC552
R596 R592
Q558
C750
+
4
R272
G
C594
7
14
R636
5
R269
+
R591
R638
VR621
R270
I
C751
8
R55
R570
IC733
C470
L222
O
R60
R637
C465
C287
13
IC216
+
C252
AGC
8
C262
I
G
R453
C462
+
R463
R471
C269
O
C254
L458
C266 C253
IC215
Q8
C48
C476
C256
R466
C487
R468
C486
7
D454
C474
R464
C464
R470
D456
C468
R455
R457
C466
C460
Q452
D
G
S
L465
C482
R454
C484
R469
D453
C463
C455
C461
6
C479
Q456
D
G
S
L457
C623
C634
C55
L14
R465
C459
Q451
D
G
S
C42
C50
R59
L466
L463
L456
L464
C481 C485
C483 C488
C478
TC451
C8
C635 +
C602
L13
C477
TC453
C49
R47
P
XF931
C633
L221
L455
D452
C472
TC452
L452
C452
L462
D455
C473
C453
5
C451
L453
D451
R452
L461
Q455
R460
L451
R850
TP
C64
C60
R61
C2
R641 C624
L9
R56
R54
C52
L19
R37
L15
R20
L31
C90
R85
R91
R93
C96
R92 C103
L454
R451
R104
1
R46
R89
C29
R23
R1
R5
R631
IC2
16
C9
C3
C579
C51
8
C628
R36
R49
O
TX-RX UNIT (X57-663X-XX) (A/2, B/2) 0-11 : KH 0-12 : KS 2-71 : EH 2-72 : ES
Component side view (J72-0878-19)
X1
L6
R24
C46
Q4
R17
C592
L30
R66
R69
C84
R63
Q15
L26
C80
Q5
Q6
9
Q10
61
R83
R65
Q18
43
R80
C94 +
L23
+ C106
+ C99
R74
C73
R96
16
R79
IC3
9
CV
L35
C22
R13
R22
R590
R90
R82
1
C23
C21 +
C120
CN3
LO1
(BLUE)
R95
C102
R71
4
R81
R72
C97
C32
1
8
Q14
R76
C91
C89
R75
C100
R108
C119
3
R86
16
C18
R10
Q7
R31
IC1
R18
C26
C30
R34
C40
R64
C121
R43
R51
R28
R39
R42
D1
C63
8
C11
R25
L11
16
L7
9
R21
C25
R48
R103
C122
34
Q9
R109
C57
N
PC BOARD
R30
C35
C36
R45
R57
R58
C61
L20
R52
C69
C65
CF1
C123
C124
L16
C54
Q11
J72-0878-19 A/2
M
PC BOARD
TX-RX UNIT (X57-663X-XX) (A/2, B/2) 0-11 : KH 0-12 : KS 2-71 : EH 2-72 : ES
Component side view (J72-0878-19)
2
L
CN403
G
Q684
16
TS-480HX/480SAT
F
L901
E
R906
D
L909
C
R142
1
B
R138
A
NBL
Layer 1
Layer 2
Layer 3
Layer 4
13
Foil side
14
A
1
B
C
D
E
TS-480HX/480SAT
F
G
H
I
J
PC BOARD
C944
R946
C985
C981
R980
R952
L558
C974
C950
C953
L971
14
Q563
C552
R565
Q561
R702
C193
C192
C191
R745
C179
C178
C177
C176
R212
C224
R220
CP216
R340
CP217
C387
R554 C554
R559
C567
R569
D551
C568
IC554
43
51
C599 R612
C600
R609
R608 TH552
R239
C237
R329
R328
R215
R237
C245
D210
R372
C235
C239 R228
R234
C234
C145
D132
R133
C138
C248
D213
C139
SQC
R768
R767
S
D
G
GND NC
C761
Q136
R148
R151
R153
DTS AIN
D138
COM BRK
C131
SPO
C759
D131
SS
C136
C757
ANO
Q131
C147
R136
D134
R145
R140
34
+
R132 C141 R137
C148
R141
C143
C149
Q133
16
R143
C142
C151
C137
R154
R135
D139
C153
GND
R144
C133 R131
RXD
RTK
D135
R152
R149
NC
RL
C146
R139
D137
RTS
RTS
NC
ALC MKE
D133
C207 C201 C202 C210
C135
R134
Q137
C152
R155 C132
CTS
RXD
L132
C134
L205
L203
L202
L204
CTS
C150
R518
L134
34
C144
D136
TXD
+
L133
R146 R147
C518
Q504
R735
C419
R803
D813
C385
R343
R227
C325
R236
D211
Q138
118
CP201
R339
C383
R815
R807
C806
R801
D734
C807
R361 R355
C230
R357
L207
C523
R516
R517
NC
8
4 5
IC227
L209
TXD
NC
C329
1
R325
R240
R520
GND
R704
R324
R362
L208
Q505
C521
C699
R707
R323
R360
R341
R510
R506
R513
G
D
S
Q503
C519
C517
CP731
R322
R358
+ C511
R519
C525
C233
C515
D501
R611
R356
R359
R508 R515
R512 R511
R514
C514
Q507
L361
R577
C570
C226
C229
L366
L505
NB
C569
R571
C738
C323
L210
C512
12
C389 +
CP732
C601
GND
L503
R509
R525
D801
R736 R741
C508
C412
D802 D804
C809
R775
C411
13
51
D733
R806
R225
L365
C410
C208
CP202
Q134
15
C409
R804
C801
C408
R738
C407
R734 C733
R732 R733
L364
C406
R737 C734
C731
C405
C804
Q731
43
C404
C802
R740 R739 C736
CP351
C403
11
R832
R851
D811
R846 C805
C402
10
R819
D805
C817
D819
R838
C808 +
C401
9
C572
SQL
C811
R837 R813
GND
C400
R854 R845
R828
R823
C384
D354
R852
R839
C818
D809
C187
C399
R206
R805
R822
C812 +
R701
L682
C397
8
C185
C803
R375
R376
R814
R682
C367
C366
R203
D353
C691
R690
C194
D558
R691
D812
R816
C364
Q562
C603
R610
R699
R714
R694
C701
R709
C190
C363
C698
R698
C702
ALC
R697
Q685
R710
L351
C398
C565
R567
R568
R351
R856
C360
C636 R656
C822
R978
C564 R566 R573 C571
C358
C365
R558
R976
Q560
R607
15
R606
34
L974
Q971
R958
C955
C934
L910
R564
C925
C359
C555
R975
R373
C362
C557
R352
C357
7
C551
R979
R949
D903
L936
D935
C952
TH971
C188 C560
R557 C556
C978
R971
R954
C979
L975
C975
R948
R953
R939
R977
C933
C954
R973
C951
R905
D351
C356
R957
R934
L933
RB
D621
R981
L976
C982
C983
RA
C958
R933
R941
D939
R942
C938
R551
C980
L935
C928
C354
C355
R938
D933
C962
R918
L932
C959
C353
L623
D937
+
R657
D938
R708
R940
C936
C927
D904
L904
C906
L906
Q624
C632 +
C915
R909
C914 TH901
R914 R912
L905
R921
C937
D622
Q622
R955
R913
D905
C352
41
C916
32
Q901
C626 R634
R628
D936
L934
D906
C909
C501
L501
C908
R904 R908
C503
R501
C528
C907
C351
5
D901
C529 R528
Q508
C502
R601
L552
R956
C977
R947
C640
R951
R645 R646
R950
C597
C943
D944
C949
C505
R504
C1
C735 R731
C984
D945
C957
C931
C932
R935
L931
R932
C905
D902
C926
Q501
L504
R931
J72-0878-19 B/2
C956 D934
TH902 R925
R503
R527
C506
R505
C504
L502
R927
R526
6
TH972 R945
D931
R605
R502
R982 R944
R937
C961
R924
L903
R902
R922
4
C960
L356
C903
L357
Q559 D557
GND
R936
C935
R602
3
R943
D940
D941
C375
C373
C376
D932
C374
C378
C379
L358
C382
2
C377
TX-RX UNIT (X57-663X-XX) (A/2. B/2) 0-11 : KH 0-12 : KS 2-71 : EH 2-72 : ES
Foil side view (J72-0878-19)
J
K
L
M
N
O
P
Q
R
S
TS-480HX/480SAT
PC BOARD
1
+
C115
C37
L10
C76
R88
R600 R595
D4
L29
L25
R462
C75
L172
C457
Q453
C196
R759
R314
R315
+ C279
R763
C368
Q737
15
+
R276
GND
C749
+
C288
C302
R273
+ C286
C303
R280
D736
34
C320
C280
C293
C369
L352
R354
C321
C290
C480
Q457
C221
8C
R757
3
4
5
6
7
8
9
10
11
Component side
SS MIC MD
MU MCG MSG NC
C413
R338
C416
R366
C417
TDO GND SPG
C418
C415
C212
SP RDO 8M
R768
R767
2
12
D359
C211
L228
L229
GND
D360
C762
R766
C759
C760
D204
C296
Ref. No. Address Ref. No. Address
IC226 12L
D138 13H
IC227
9J
D139 12G
IC554
7H
D203 12M
IC685
8K
D204 12N
Q2
2L
D206 12N
Q3
4L
D210 11H
Q13
3O
D211 11H
Q16
4P
D213
12J
Q19
2O
D351
6B
Q131
12I
D352 10N
Q133
12I
D353
7E
Q134 12F
D354
7D
Q136 13H D359 13O
Q137 12H D360 12O
Q138 13G D501 12B
Q205 10M D551
6I
Q453
7P
D552
5K
Q454
7N
D557
3B
Q457
7O
D558
7D
Q501
4B
D621
3J
Q503 12B D622
3J
Q504 12C D623
4J
Q505 13B D733 10C
Q507 13B D734 10C
Q508
5B
D736 11O
Q552
5L
D801
9D
Q553
6L
D802
9C
Q557
6L
D804
9C
Q559
3B
D805
8D
Q560
5I
D809
8B
Q561
6J
D810
7K
Q562
7D
D811
9C
Q563
4I
D812
8D
Q622
3J
D813
9E
Q623
5K
D819
8C
Q624
3J
D901
4C
Q625
3J
D902
4D
Q685
7C
D903
6D
Q686
8K
D904
4D
Q731
9C
D905
5C
Q734
8P
D906
4D
Q737 10N D931
3D
Q805
8K
D932
2D
Q901
5D
D933
5D
Q971
5H
D934
3F
D2
4N
D935
5G
D3
4N
D936
3F
D4
4Q
D937
4G
D131
12I
D938
4G
D132
12I
D939
5D
D133 13G D940
2D
D134
12I
D941
2D
D135 12H D944
2E
D136
12F
D945
2E
D137 13H
C223
R769
C222
D203
L227
R337
R211
C218
C328
C248
D213
R283
R336
R284
15
34
R344
R327
C327
IC226
D206
R275
C747
R246
L219
C309
R254
R374
R353
R286
+
C753
L353
+ C310
D352
R287
C314 C312
R277
R334
C371
R309 R311
Q205
R335
C372
L354
C274 +
L220
C186
C107
C197
L226
L355
C370
C272
R302
C182
C326
C292 C270
R297
+ C247
AF
+ C258
C250
R756
L174
R308
R285
C244
C181
C255
C268
G
D
S
R762
C271 +
C458
Q454
8
5
C227
R251
R242
C251 R247
+
Q734
R751
C742 R765
C257
C249
R255
GND
L175
C261
C260
R274
R248
R711
R282
Q805
+
51
IC685
43
C681
C704
C108
C180
L171
C225
C171
C175
C595
C746
R597
Q557
C764
R712
C329
C757
C72
C74
L27
Q16
C118
C83
C86
R78
C56
C62
C43
C92
C95
R77
R99
R53
C39
C44
R98
R97
L21
C67
+ C87
C77
+ C689
+
R715
C761
R94
R110
R306
+
C78
L212
C688
+
CP220
R688
C686
R686 R713
C690
+
C173
D810
C174
C172 R318
R681
C93
C85
R73
C104
L28
C593
C745
R598
C591
C590
C189
R708
C700 R703
R702
L24
C741
R687
R704
R70
GND VCO
C71
R752 R750
+
GND
R707
C31
L5
C59
C58
R572
R599
C699
R84
C53
GND
C70
Q553
R604
R579
C596
C575
R611
C66
Q552
R580
Q686
70
C117
L34
R461
Q561
71
D2
C79
+
CV
L22
L18
6 R573 C571
R577
51
AGC
R576 R578
D552
C12
C17
R16
C563
69
Q13
43
C88
R15
Q3
C630
R68
D3
R8
+ C639
L622
Q623
C629
C68
R35
L625
C637 R643
L624
C10
C81
R67
L12
+
R29
R632
R559
R633
C24
C20
C33
C34
R27
C573
R653
34
C638
C631
C555
L552
R554 C554
C556
R651
R650
+
C188 C560
C641 +
R629 C625
R551
+
GND
R642
D623
C559
L623
C644
R654
R648
R640
D621
C636 R656
R657
2 +
R105
C28
+ C642
R655
C640
R645 R646
Q625
16
+
R19
C643
R652
D622
628
C15
Q19
C4
C16
L626
626 R634
R106
C47
R44
L8
C5
L4
L1
L3
R32
R38
R3
R7
R107
R102
C116
C19
J72-0878-19 A/2
C38
C6
Q2
R100
R6
15.6M
R101
TX-RX UNIT (X57-663X-XX) (A/2, B/2) 0-11 : KH 0-12 : KS 2-71 : EH 2-72 : ES
Foil side view (J72-0878-19)
Layer 1
Layer 2
Layer 3
Layer 4
13
Foil side
119
14
H
I
J
K
R100
C115
C37
R107
C76
R88
D4
L25
R462
C75
C271 +
L355
C309
R254
L353
+ C310
Q205
R374
R314
C368
Q737
15
C321
+
GND
C749
R273
+ C286
+
C303
R280
R276
D736
34
C320
C280
R277
C369
L352
R354
R353
R286
C314 C312
R315
C753
R763
R309 R311
+
C293
Q453
C371
C370
C274 +
C290
C186
C372
L354
R308
R287
C480
R759
C196
L172
AF
C182
S
1
C221
R757
D360
2
3
4
5
6
7
8
9
10
11
C415
D359
8C
C416
R366
C413
Component side
SS MIC MD
MU MCG MSG NC
R768
R338
12
C417
TDO GND SPG
C418
R769
C212
SP RDO 8M
C762
R337
C211
Ref. No. Address Ref. No. Address
IC226 12L
D138 13H
IC227
9J
D139 12G
IC554
7H
D203 12M
IC685
8K
D204 12N
Q2
2L
D206 12N
Q3
4L
D210 11H
Q13
3O
D211 11H
Q16
4P
D213
12J
Q19
2O
D351
6B
Q131
12I
D352 10N
Q133
12I
D353
7E
Q134 12F
D354
7D
Q136 13H D359 13O
Q137 12H D360 12O
Q138 13G D501 12B
Q205 10M D551
6I
Q453
7P
D552
5K
Q454
7N
D557
3B
Q457
7O
D558
7D
Q501
4B
D621
3J
Q503 12B D622
3J
Q504 12C D623
4J
Q505 13B D733 10C
Q507 13B D734 10C
Q508
5B
D736 11O
Q552
5L
D801
9D
Q553
6L
D802
9C
Q557
6L
D804
9C
Q559
3B
D805
8D
Q560
5I
D809
8B
Q561
6J
D810
7K
Q562
7D
D811
9C
Q563
4I
D812
8D
Q622
3J
D813
9E
Q623
5K
D819
8C
Q624
3J
D901
4C
Q625
3J
D902
4D
Q685
7C
D903
6D
Q686
8K
D904
4D
Q731
9C
D905
5C
Q734
8P
D906
4D
Q737 10N D931
3D
Q805
8K
D932
2D
Q901
5D
D933
5D
Q971
5H
D934
3F
D2
4N
D935
5G
D3
4N
D936
3F
D4
4Q
D937
4G
D131
12I
D938
4G
D132
12I
D939
5D
D133 13G D940
2D
D134
12I
D941
2D
D135 12H D944
2E
D136
12F
D945
2E
D137 13H
C223
L228
GND
C218
D206
C328
R283
R284
C296
L229
C760
C759
D138
GND NC
R766
SQC
R767
S
D
G
C222
D204
C761
R153
DTS AIN
Q136
C133 R131
R151
C136
R148
COM BRK
C131
SPO
R211
D203
D131
SS
R344
R327
C138
C248
D132
C139
15
34
R336
C757
ANO
C147
IC226
D213
R133
C142
Q131
R136
D134
34
C327
C145
R145
R140
Q133
16
R132 C141 R137
C148
C143
C149
R141
GND
C747
L219
+ C247
C326
L220
R756
L174
C272
R334
C181
C255
C268
R297
R246
C197
C244
+ C258
C250
G
D
S
C742 R765
C257
R251
Q734
R751
R762
8
R285
+
R242
C329
C251 R247
C260
R282
C249
GND
L175
C261
R255
R248
R274
Q457
C108
+
L226
L212
C107
L171
C225
C180
R306
IC685
43
Q686
Q805
R711
C458
Q454
C746
R597
R600 R595
C593
C745
R752 R750
R598
C595
C292 C270
+
C72
C74
L27
Q16
L29
R78
C43
R53
C118
C83
C44
C39
C56
C62
C86
C95
R77
R99
C92
+ C87
C77
R712
R335
R144
R94
R110
C171
C175
C173
C78
51
+
C245
R237
C85
R73
C104
L28
Q557
C764
R302
R143
C151
R154
RTK
R152
C137
RL
D139
R135
L132
ALC MKE
C153
R134
D135
R139
R149
NC
RXD
C135
C146
D137
RTS
RTS
NC
+
Q137
C152
C207 C201 C202 C210
RXD
L10
C47
R44
L8
R98
R97
L21
L24
+ C689
C704
D210
C239 R228
R372
C235
C38
R101
L1
C4
C24
C67
C59
C58
R572
C71
C234
R146 R147
34
C150
L205
L203
L202
L204
CTS
C134
CTS
TXD
C93
GND
GND VCO
+ C279
R234
C117
L34
R70
+
CV
C70
Q553
R604
C688
R688
C686
R686 R713
C690
C700 R703
D810
C174
C590
C189
R220
CP216
C31
L5
R35
C17
R576 R578
L622
R632
Q561
R702
R708
+
CP220
4 5
IC227
CP217
R38
R3
C20
C33
C34
L625
C637 R643
L624
R629 C625
Q623
C573
R653
R651
R650
R640
D621
C640
R645 R646
Q625
16
R554 C554
R559
R569
D551
C193
C192
C191
C179
R745
C178
C177
C176
+
+
R212
C224
R215
R340
C387
C596
C591
C172 R318
R681
1
C66
Q552
R565
C565
R567
C568
IC554
43
51
C599 R612
C600
R609
R608 TH552
R239
R343
C237
R329
R328
D813
C385
R735
C419
D353
R803
R807
R518
D136
Q138
14
CP201
R339
C383
R815
R819
D805
R361 R355
D802 D804
R801
D734
C807
C518
Q504
C144
L134
C523
R516
NC
NC
R704
51
L22
C741
C325
R236
L133
L207
TXD
GND
+
GND
R707
C88
R275
R155 C132
C521
CP731
R68
R84
C288
D133
Q507
C517
L18
R599
C699
C81
R67
C79
AGC
C575
R611
R105
Q13
43
D2
C53
L209
R520
Q505
C525
R525
C519
D552
C630
C12
R579
D211
R341
R510
R506
R513
R519
R16
C230
R357
+ C511
R517
Q503
C514
C570
Q19
R15
Q3
R325
R240
L208
D501
C68
R324
C515
R512 R511
R514
G
D
S
NB
12
R360
L366
C508
R509
R571
R106
D3
R8
+ C639
R580
R323
R362
R508 R515
C512
C10
R322
L210
L505
11
C233
R
TS-480HX/480SAT
R461
R715
C229
GND
L503
R577
R32
L12
+
R29
R356
R359
R736 R741
R27
C563
C569
C738
C323
R227
R775
C411
C412
13
C809
D733
R633
C226
R225
L365
C410
CP732
C601
CP202
Q134
15
C409
L361
C801
C408
C389 +
C641 +
C638
C629
+
GND
R687
R358
R738
C407
R734 C733
R732 R733
L364
C406
51
C731
C405
C804
Q731
43
C404
C802
R737 C734
C403
R740 R739 C736
CP351
C402
10
D801
R846 C805
C401
9
R804
R806
C806
GND
C400
R832
R851
C399
D811
C208
C644
R654
R642
C572
SQL
C811
C808 +
R823
D354
R852
C817
D819
R701
C384
R854 R845
R828
R837 R813
C812 +
R206
R805
R822
R838
C187
R839
C818
D809
C398
L682
C397
8
R203
R375
R376
R814
C803
C366
C185
R691
D812
R816
C367
Q562
C603
C691
R690
C194
D558
R682
C364
C365
R610
R699
R714
R694
C701
R709
C190
C363
C698
R698
C702
ALC
R697
Q685
R710
L351
C362
C567
R351
R373
C360
C555
R655
C564 R566 R573 C571
C358
R856
Q
C28
R564
C925
C359
C636 R656
C822
R978
R979
R352
C357
7
R558
Q560
R607
15
R606
34
R976
R977
L974
Q971
C975
R948
D935
C952
C557
R19
+ C642
R975
R949
R958
C955
C934
L936
R557 C556
C15
C643
D623
+
C188 C560
C551
C978
TH971
R568
R905
D351
R939
C979
L975
R971
R954
RB
R551
Q563
C552
C954
R953
C5
L4
R648
C559
R981
L976
C982
C983
RA
R957
R934
C951
L910
C354
C356
R973
L935
C928
C355
C933
R933
R941
D939
R918
C962
R942
L933
C959
C353
L623
C980
D903
D905
C938
+
R657
C735 R731
R940
C936
D904
L906
Q624
D938
D933
R913
C906
L905
R914 R912
C914 TH901
R904 R908
R921
L904
C909
41
C916
32
Q901
Q622
D937
R938
D622
C631
L558
L971
C16
L626
C626 R634
C632 +
L932
R7
+
R628
R955
C937
P
J72-0878-19 A/2
R102
R601
D936
C915
C908
C351
C352
R909
C907
C503
R501
C528
R526
5
C501
C529 R528
Q508
C502
L501
R527
R504
C6
C944
C950
C974
L3
C19
L552
R956
R937
R946
C985
C943
D944
C977
R947
C505
D901
Q2
C116
C981
R980
R951
D906
TH902 R925
R503
C949
L934
C958
R927
15.6M
R950
C953
R6
C1
C597
C984
D945
C957
C931
C932
L931
R932
C905
C926
Q501
L504
R505
C504
L502
C506
R922
6
R935
O
TX-RX UNIT (X57-663X-XX) (A/2, B/2) 0-11 : KH 0-12 : KS 2-71 : EH 2-72 : ES
Foil side view (J72-0878-19)
J72-0878-19 B/2
C956 D934
D931
R605
R502
TH972 R945
R952
C927
R924
C903
L903
R902
D902
GND
R931
N
PC BOARD
R982 R944
D941
C961
C374
Q559 D557
3
R936
C935
R602
4
C960
C373
L356
C375
C376
C377
C378
L357
C379
L358
C382
2
R943
D940
M
PC BOARD
TX-RX UNIT (X57-663X-XX) (A/2. B/2) 0-11 : KH 0-12 : KS 2-71 : EH 2-72 : ES
Foil side view (J72-0878-19)
D932
L
C457
G
C302
TS-480HX/480SAT
F
L227
E
D352
D
C681
C
R652
1
B
34
A
Layer 1
Layer 2
Layer 3
Layer 4
13
Foil side
14
A
B
C
TS-480HX/480SAT
D
E
SCHEMATIC DIAGRAM
X201
22p
DRE
RST
L77-1907-05
22.1184M
C228
PLAY
BUSY
REST
TSO
FEN2
TSI
TTO
CLK
DATA
IEN1
IEN2
HWR
HRD
C227
22p
FANH
FANL
FEN1
PSC2
PSC1
ATEN
PRGS
REN
TX-RX UNIT (X57-663X-XX)(A/2)
1
3V
VCO1
VCO2
VCO3
UL
R206
CP212
1k
3.31V
IC203
ADM202EARU
15k
MA2S111
PLAY
BUSY
C238
330u6.3
0.01u
47k
CP228
47k
47k
R224
100
CP225
R225
100
CP224
C233
100
CP222 100
IEN3
DACK
DADT
SPS
BKC
BOVR
TYPX
100
R372
47k
R322
R323
R324
R325
4.7k
STPA
BOVR
STPC
47k
470k
47k
CP226
1k
CP223
100
R240
47k
14V
47k
3C
2
7
3
6
4
5
IC207
HD74LV2G34AUS
C237
0.01u
0V
1A
0V
3Y
0V
2A
0V
GND
3.32V
VCC
3.32V
1Y
0V
3A
3.32V
2Y
R343
1
8
100
100
8
CTS1
RXD1
R341
3.29V
VCC
3.30V
1Y
4.0V
3A
3.29V
2Y
7
TTI
6
5
TSI
IC209
HD74LV2G34AUS
BUFFER IC
TXD1
TXD0
RTS1
7
6
1
5
5
VCC
Y
IC226
HD74LV1GT125A
4
BUFFER IC
100
A
3 0V
GND
RS1
TD1
TT
TS
L212
DEN2
PCK
DEN1
PEN
0V
oE
2
R336
IC208
TC7WT125FU
BUFFER IC
R344
100
C327
0.01u
100
BUFFER IC
100
R342
8
TD0
4
0.01u
4.87V
VCC
0V
G2
0V
Y1
3.29V
A2
100
IC225
TC7WT125FU
3
R328
R329
R340
5
C232
0V
G1
0V
A1
4.87V
Y2
0V
GND
R333
6
100
2
10k
10k
7
R332
100
R319
1
R320
100
19
18
17
16
14
R318
100
CP220
100
13
12
TSO
TTO
DENB
1
A1
0V
G1
2
DENA
PDCK
PDDA
4
3
A2
5
A4
A3
PENA
7
8
9
10
0V
GND
0V
A8
0V
A7
0V
A6
0.01u
8
14V
5C
14V
10k
5C
TXB
VSR
VSF
PHD
AMD
FEN2
CLK
DATA
I5C
R374
3.9k
(D)
8C
14AG
14AF
VDT1
ATEN
IC2-
IC2+
TXB
ODP
CLK
DATA
FEN1
PSC1
THP1
IC1-
IC1+
14S
L358
10u
0.1u
100p
100p
100p
100p
100p
0.01u
C374
C375
C376
C377
C378
C379
C382
L357
12
11
10
9
8
7
6
5
4
1
8 0V
7 0V
3
0.1u
0.1u
0.1u
C372
CN369
E40-3252-05
FINAL UNIT
X57-365X-XX(A/3)[AT]-CN2
X57-366X-XX(A/3)[200W]-CN2
FINAL UNIT
X57-365X-XX(A/3)[AT]
CN8
X57-366X-XX(A/3)[200W]
CN8
FINAL UNIT (ANT)
X57-365X-XX(C/3)[AT]
CN502
X57-366X-XX(C/3)[200W]
CN502
TXB
GND
VSR
VSF
PHD
AMD
GND
FEN2
CLK
DATA
14S
5C
GND
GND
5V
8C
14S
14AF
14AG
CN375
E40-5758-05
14V
IC2+
ATEN
PSC2
IC2-
TH2
TXB
ODP
VDT2
CLK
DATA
TH1
FEN1
PSC1
IC1-
IC1+
FANL
FANH
GND
CN359
E40-5978-05
0V
13.64V
2
0.1u
C371
0.1u
C369
C370
6 7.87V
5 4.89V
4 13.74V
3
2 13.71V
0.1u
1000p
C367
C368
0.01u
C366
1 13.76V
0.01u
C365
18
0.01u
C364
17
0.01u
C363
16
0.1u
C362
15
14
13
100p
0.01u
C359
100p
C358
C360
12
11
100p
C357
10
0.01u
C356
9
0.01u
C355
8
7
6
0.01u
C354
5
0.01u
0.01u
0.01u
C351
C352
C353
4
3
4.85V
C373
L356
L355
L354
L353
L352
KDZ18EV
D352
VSR
LIMITER
2
1
10k(D)
L351
R353
*
R354
39k
(D)
R373
*D351
*
015AZ10-Y
R351
*
R352
FANL
FANH
13.12V
VDT2
D206
1u
0.01u
4.76V
VCC
3.28V
G2
4.75V
Y1
3.28V
A2
13.75V
AVR
Q201
2SC4617(R)
C218
C323
14V
0V
X57-663 (A/2) 1/7
CP232
BUFFER IC
1 3.28V
G1
2 3.28V
A1
3 4.75V
Y2
4 0V
GND
LIMITER
120
0.01u
GND
0V
Y8
0V
Y7
0V
Y6
0V
Y5
0V
Y4
0V
Y3
0V
Y2
0V
Y1
0V
G2
4.75V
VCC
C225
11
1000p
1000p
015AZ6.8
IC205
HD74HCT541T
BUFFER IC
10V ZENER DIODE
7
HD3
HD2
HD1
HD0
SQC
PKP
LNA2
LNA1
C223
R211
9.51V
10.07V
6
C222
D203
015AZ6.8
D204
1000p
C212
1000p
9.45V
AVR Q202
2SB1188(Q,R)
0.01u
C221
0.1u
C418
10u
D203,204
LIMITER
POLY-SWITCH
D202
MINISMDC050-02
C214
L227
C211
R338
J202
E58-0506-05
50W
47k
SP
RD0
TD0
100u
100u
L229
L228
R321
0
015AZ3.3-X
D207
100k
LIMITER
100u16
TDO
RDO
GND
8M
SPG
C236
BKC
STPC
R210
1000p
1000p
C202
C210
1000p
1000p
C201
C207
D205
1 SP
2
3
4
5
6
CP217 47k
RK75GB1J473J
GND
R209
RXD0
2.84V
RD1
R327
SP
TDO
RDO
GND
8M
SPG
CP221
0.01u
4
REVERSE
CURRENT
PREVENTION
100u
100u
100u
100u
L202
L203
L204
L205
0
5
DISPLAY UNIT
X54-3410-00(A/3)
J2
COM
NC
NC
RXD
RTS
TXD
CTS
NC
NC
GND
0.01u
TT
TS
3.3u
L210
3
TD1
J201
E58-0435-05
1
6
2
7
3
8
4
9
5
HD7
HD6
HD5
HD4
CP231 100
RD0
9
4.80V
1A
3.29V
3Y
4.80V
2A
0V
GND
2
CS1
RD1
3.3u
1
RS1
* R223
L209
10
C234
0.01u
D208
KDS121E
CS1
R221 1k
3.3u
R220
47k
3.3u
L208
* R217
* R218
L207
11
THP2
8
12
10u
7
1u
C235
PHSW
RXD1
RXD0
TXD1
TXD0
3C
3V
CP216 47k
RK75GB1J473J
REVERSE
CURRENT
PREVENTION
6
6
13
A5
5
14
15
1u
C206
15
STS
4
VCC
0V
GND
9.53V
T1out
0V
R1in
4.80V
R1out
0V
T1in
4.87V
T2in
4.80V
R2out
1u
C205
7.1V
C1+
9.53V
V+
2.35V
C14.64V
C2+
-4.84V
C2-9.46V
V-9.45V
T2out
0V
R2in
AMU
100
3C
3V
5V
4.86V
47k
3
TCS
R227
47u
R326
2
1u
C217
1u
C204
L211
16
3C
PDA
L201
3.3u
4
1
0.01u
C220
C203
CP219
47k
C229
CP215
TSO
FEN2
3.32V
SWITCHING
Q203
RN47A5
4.82V
CTS1
RTS1
STS
TXC
CKY
ABK
BEEP
DRES
MIC
VOS
SSR
PKSR
HCS
3V
1k
LEVEL CONVERTER
72
71
70
69
68
67
66
65
64
63
62
61
60
59
58
57
56
55
54
53
52
51
50
49
48
47
46
45
44
43
42
41
40
39
38
37
CP230
DASH
DOT
KYS
KEY
R203
TYP4
TYP5
TYP6
TYP7
CP204
47k
0.01u
S201
S62-0412-05
C230
GND
20
GND
47k
STPA
STPC
TYP0
TYP1
TYP2
TYP3
EEPROM
TSI
TTO
CLK
DATA
IEN1
IEN2
HWR
HRD
NC
FWE
VCC5
NC
VSS7
EXTL
XTL
VCC4
STBY
NMI
REST
NC
FANH
FANL
FEN1
PSC2
PSC1
ATEN
PRGS
REN
RST
NC
DRE
NC
108
107
106
105
104
103
102
101
100
99
98
97
96
95
94
93
92
91
90
89
88
87
86
85
84
83
82
81
80
79
78
77
76
75
74
73
PDCK
PDDA
100u
4
PSC2
3
0.01u
2
MD2
IC204
HD64F2338VFC25
WAIT
HA0
HA1
HA2
HA3
1
CP211
100
MCU
CTS1
VSS6
RTS1
STS
TCS
AMU
PHSW
RXD1
RXD0
TXD1
TXD0
VCC3
HD7
HD6
HD5
HD4
VSS5
HD3
HD2
HD1
HD0
SQC
PKP
LNA2
LNA1
VSS4
IEN3
DACK
DADT
SPS
BKC
BOVR
TYPX
VCC2
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
3
CP210 100
RBK
DENB
DENA
PENA
MD0
3.29V 8
CS
VCC
7
SO
HOLD
6
WP
SCK
5
GND 0V
SI
100
CP209 100
0.01u
IC202
AT25640N10SI27
0.01u
C224
CP208
3V
ADC1
ADC2
EEN
EDA
ECK
ESI
C209
CP207 1k
SM
SQL
GND
CP202
47k
R215
CP213
47k
47k
AXC
AYC
DRO
PKD
8
CP206
1k
VDT1
VDT2
VSFM
VSRM
FIL2
5V
GND
CP233
100
VCC1
WAIT
HA0
HA1
HA2
HA3
VSS1
NC
NC
NC
NC
TYP0
TYP1
TYP2
TYP3
VSS2
TYP4
TYP5
TYP6
TYP7
DASH
DOT
KYS
KEY
VSS3
TXC
CKY
ABK
BEEP
DRES
MIC
VOS
SSR
PKS
7
3V
THP1
TTI
TYPY
AMD
PHD
AVCC
VREF
VDT1
VDT2
VSFM
VSRM
AXC
AYC
SM
SQL
AVSS
VSS8
ADC1
ADC2
EEN
EDA
ECK
ESI
RBK
DENB
DENA
PENA
MD0
MD1
MD2
PDCK
PDDA
VCO1
VCO2
VCO3
HCS
UL
CP214
100
6
109
110
111
112
113
114
115
116
117
118
119
120
121
122
123
124
125
126
127
128
129
130
131
132
133
134
135
136
137
138
139
140
141
142
143
144
DRO
PKD
5
THP2
47k
4
ALM
CP205
1k
TTI
TYPY
AMD
PHD
FIL1
47k
3
R212
2
AYC
R371
2
MD
47k
CP201
1
MU
R202
3.31V 16
0Y
VCC
15
2Y
2X
14
Y-COM
1X
13
3Y
C-COM
12
1Y
0X
11
INH 0V
3X
10
VEE 0V
A
9
GND 0V
B
R201
100
MULTIPLEXER
IC201
TC74HC4052AFT
C226
47k
R339
3C
100
0.01u
C208
100
3V
F
G
H
I
J
TS-480HX/480SAT
SCHEMATIC DIAGRAM
TX-RX UNIT (X57-663X-XX) (A/2)
C282
0.1u
20.5mVp-p
HD4
HD5
0.1u
D2
D1
D0
12.288MHz
X202
L77-1920-05
DRES
HD3
R312
27p
GND
3C
R335
HD2
4.7k
R334
GND
3C
C307
0.1u
10k
R296
C300
0.01u
100
C298
0.1u
R287
C294
0.01u
100
R282
1.80V
2C
3C
HA0
R297
10k
HA1
INVERTER
WAIT
HA1
R285
100
HD0
SDTI
3.32V
GND
DSPGND
1k
2.2k
10
9
1.61V
AOUT
3.23V
V+
8
2
1.59V
A-IN
2.46V
BOUTPUT
7
R303
3
1.58V
A+IN
2.47V
B-INPUT
6
22k
4
0V
V-
2.46V
B+INPUT
8
62.1mVp-p
C304
5 0.022u
0.01u
C316
0.01u
10u
R310
1000p
C308
R305
C305
0.022u
1k
C311
R298
330k
100k
R337
R283
100k
1u
R307
1k
MIC AMP
DRO
10u6.3
C303
REF1.6V
C302
0.1u
10.2mVp-p
R301
0
1
L223
MIC
1u16
11
R293
12
DRO
C328
R284
100k
REF1.6V
10u6.3
C309
2.2k
R292
4.7k
13
DET
PKD
ANO
14S
ANO
17
18
TXB
GND
1000p
1000p
1000p
C416
C417
D358
MU
RLS245
D359
1SS388
D356
1SS388
D355
1SS388
10u10
C415
MD
NC
MIC
MSG
SS
MCG
8C
MU
1000p
R366
47
D357
8C
MINISMDC050-02
SS
R365
47
R364
47
16
RXB
8
7
6
5
4
3
2
1
15
14S
12
REN
14
11
CLK
8C
10
DATA
13
9
3C
8
7
PGC
PRES
6
AGC
CKYS
5
KYS
RF UNIT
X44-327X-XX-CN309
D360
C414
POLY-SWITCH
C413
L365
L366
C420
0.1u
C409
470u16
0.1u
C408
0.01u
100p
C407
C412
100p
C406
L364
100p
0.1u
1000p
C404
C405
0.01u
1000p
C403
C411
1000p
C402
REVERSE
CURRENT
PREVENTION
C410
1000p
C401
L363
L362
CP351
1000p
1000p
C399
1000p
C398
4
MD
7.85V
VOAF
TXB
RXB
100u
10u
10u
8C
10u
3C
REN
CLK
10u
DATA
PRGS
PGC
TIFM
KYS
DOT
100
D355,356,358,359
C400
1000p
C388
C393
C395
C397
3
1 2
DOT
3 4
SO
BUSY
2
5 6
CLK
KEY
7 8
USEL
CN403
E40-5978-05
GND
9 10
1
EXT.AT
DGND
AO 11 12
AGND 13 14
15 16
17 18
19 20
21 22
23 24
25 26
TT
CN390
E40-6357-05
D357
POLY-SWITCH
13.23V
DASH
PLAY
SI
EN
RST
AGND
C390
C392
C391
C394
C386
C389
AI
5C
3.28V
0V
1
3
2
TS
CN382
E40-3247-05
DASH
KEY
VOI
1u
C387
R356
100
100p
100p
1000p
100p
100p
100p
1000p
100p
10u6.3
1000p
C384
4.84V
AGC
AF
CLK
BUSY
R360
R362
100
100
PLAY
100
R357
R359
R358
100
100
DATA
RST
100
10u
L361
R355
100
100
R376
1000p
C383
7.73V
GND
C419
0.1u
R375
R361
D353
DA221
14S
1u
C385
LIMITER
100
TT
TS
D354
DA221
DRE
DRM
5C
LIMITER
VOO
14S
5C
100
0.1u
IC221
NJM2100V
R300
330k
DRO TX
7
C301
22k
22k
R280
C293
2700p
22k
R277
6
1u
C290
5
14
R294
3
4
22k
5
3.23V
VDD
0V
C1
3.23V
C4
1.58V
I/O4
1.56V
O/I4
1.57V
O/I3
1.56V
I/O3
R289
2
C291
470p
6
22k
10u6.3
C288
0.1u
C286
22k
22k
10k
R267
R331
7
R276
10k
22k
R330
1u
0.01u
IC219
BU4066BCFV
1.56V
I/O1
1.57V
O/I1
1.57V
O/I2
1.56V
I/O2
0V
C2
0V
C3
0V
VSS
1
PKD
R275
C259
8
C265
1000p
IC214
NJM2100V
FILTER AMP
1u
22k
1
3.23V
V+
1.57V
BOUTPUT
1.57V
B-INPUT
1.57V
B+INPUT
22k
1.58V
AOUT
R264
3.23V
V+
8
22k
2
2700p
1.58V
A-IN
R265
1.58V
BOUTPUT
R262
7
18k
C273
3
NJM2100V
R273
13
1.58V
A+IN
1u
C279
DRM
C326
1.58V
B-INPUT
470p
10u6.3
C280
0.1u
ANO
14
6
IC218
1.58V
AOUT
2 1.58V
A-IN
3 1.58V
A+IN
4 0V
V-
C275
C264
C276
15
4
R261
C250
1000p
16
0V
V-
5.6k
17
1.58V
B+INPUT
1u
5
0.01u
1
8200p
19
C285
8.2k
R258
0.1u
R266
C257
22k
R255
C263
0.1u
10u6.3
C261
C260
22k
R251
0.1u
C258
8200p
10u6.3
20
C255
C249
1u
C251
21
8.2k
R247
C247
22
18
R308
REF1.6V
ANALOG SWITCH
C296
0.1u
4.7k
C315
R286
C267
FMT
PKD/DRO/MIC
ANTI-ALIASING FILTER
R259
DADT
23
18k
DACK
24
R248
IEN3
1.5V
VIN8
1.5V
VOUT8
1.5V
VOUT7
1.5V
VIN7
0V
GND
3.29V
RESET
1.5V
VDAref
3.3V
DO
1.5V
VIN6
1.5V
VOUT6
1.5V
VOUT5
1.5V
VIN5
5.6k
VOO
DET IN
3C
10u6.3
1 0V
VIN1
2 1.5V
VOUT1
3 1.5V
VOUT2
4 0V
VIN2
5 3.3V
VDD
6 3.22V
LD
7 3.29V
CLK
8 0V
DI
9 0V
VIN3
10 0V
VOUT3
11 0V
VOUT4
12 0V
VIN4
VOI
AF OUT
REF1.6V
3C
IC212
M62364FP
R242
A/D
0.1u
VOS
DRO
L219
4.27mVp-p
C244
PKD
MIC
FMOD
SMOD
27p
470k
C317
3C
2C
C318
0.01u
C306
MINISMDC050-02
J351
E58-0507-05
MIC
VGS-1
121
X57-663 (A/2) 2/7
4.7k
C299
C295
0.1u
C297
0.01u
A9
A8
A7
A6
A5
A4
HD6
A3
A2
A1
A0
DVDD
HDS2
VSS16
HDS1
NC16
CVDD6
HD5
D15
D14
D13
HD4
D12
D11
D10
D9
D8
D7
D6
DVDD5
VSS15
NC15
A19
NC18
NC17
CVDD7
2C
3C
SDTO
HA2
1u
1u
C272
C292
0.01u
C271
10u6.3
C268
100u
100
100
100
2
1
Q205
KRC402E
L226
100u
NC12
NC11
10k
10k
10k
3
NC6
R290
R291
R295
4
DSP
IC220
D3
0
5
D4
108
107
106
105
104
103
102
101
100
99
98
97
96
95
94
93
92
91
90
89
88
87
86
85
84
83
82
81
80
79
78
77
76
75
74
73
R302
6
3.17V
3C
D5
A16
D5
D4
D3
D2
D1
D0
RS
X2/CLKIN
X1
HD3
CLKOUT
VSS13
HPIENA
CVDD5
NC14
TMS
TCK
TRST
TDI
TDO
EMU1/OFF
EMU0
TOUT0
HD2
NC13
CLKMD3
CLKMD2
CLKMD1
VSS12
DVDD4
320VC5402PGE
R278
R279
R281
PWDA
14V
D6
A18
A17
VSS14
SCLK
MCLK
LRCK
PWAD
14
DRM/ANO
SMOD/FMOD
D7
GND
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
71
72
13
GND
R239
10k
10k
NC1
NC2
VSS1
DVDD1
A10
HD7
A11
A12
A13
A14
A15
NC3
HAS
VSS3
NC4
CVDD2
HCS
HRW
READY
PS
DS
IS
R/W
MSTRB
IOSTRB
MSC
XF
HOLDA
IAQ
HOLD
BIO
MP/MC
DVDD2
VSS5
NC5
100
SCLK
SCLK
18V ZENER DIODE
R269
R270
R274
12
10u6.3
VCOM
MCLK
MCLK
C274
1.42V
AOUTR
11
14V
SDTO
7
C270
1.42V
AOUTL
16
LRCK
LACK
KDZ18EV
0.1u
15
SDTO
0V
DEM1
3.18V
DEMO
3.18V
VDD
0V
VSS
1.4V
AINL
1.4V
AINR
10
0.01u
SDTI
SDTI
5
144
143
142
141
140
139
138
137
136
135
134
133
132
131
130
129
128
127
126
125
124
123
122
121
120
119
118
117
116
115
114
113
112
111
110
109
L220
8
9
13.74V
IOST
100u
IC217
AK4550VT
10k
R254
47k
CODEC
C243
0.01u
6
100u6.3
C289
0.01u
C287
100u6.3
C281
0.1u
10k
R272
HRW
1
D212
C324
HCS
HA3
VEE1
NC
2Y
7
NC7
NC8
HCNTL0
VSS6
BCLKR0
BCLKR1
BFSR0
BFSR1
BDR0
HCNTL1
BDR1
BCLKX0
BCLKX1
VSS7
HINT/TOUT1
CVDD3
BFSX0
BFSX1
HRDY
DVDD3
VSS8
HD0
BDX0
BDX1
IACK
HBIL
NMI
INT0
INT1
INT2
INT3
CVDD4
HD1
VSS9
NC9
NC10
VEE2
5 3.29V
VCC
SWITCHING
Q204
0V
KRC401E
*
C284 0.01u
3C
RESET IC
TYPY
0.01u
0.01u
C256
C252
10u10
10u10
C253
1
3
BOVR
0V
3C
VOUT
VSS
2
47k
R235
C240
0.1u
REST
10k
3.32V
3
VIN
0.1u
C254
10k
IC211
PST9130NR
R271
2
5C
4 3.27V
OUT
HD7
IC215
XC6203P332P
3.3V AVR
4.75V
1
NC
1
10u6.3
C269
4.99V
VCC
LIMITER
VOUT
VSS
C262
5
2C
1.86V
GND
VEE2
VEE1
3V
R231
3
3.27V
OUT
2
R234
47k
R237
R228
47k
0.1u
C239
IC210
PST9130NR
4
VIN
10
RESET IC
D210
MA2S111
D211
015AZ3.3-X
BKC
REVERSE
CURRENT
PREVENTION
3
C266
15k
3A
GND
0V
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
C283
0.1u
2
5C
2A
8
2C
L221
0.1u
C245
1u
C325
1.8V AVR
IC216
XC62FP1802P
4.16V
3V
0.01u
C329
0
47k
1k
R253
10u
GND
R246
1Y
3C
2C
L222
14V
3.32V
VCC
3Y
3
4
GND
R236
1A
2
5C
4.76V
3.19V
5V
HD6
HWR
HRD
3C
BUFFER IC227
HD74LV2G34AUS
1
R260
SWITCHING
Q207
HN7G01FU
10k
0.1u
R252
C246
1
4.87V
5V
330u6.3
C248
10u6.3
0.1u
C242
2 5V
VOUT
VIN
VSS
10u
C241
D213
RLS245
4.07V
3V 3
3V
R256
3.3V AVR
IC213
XC6203P332P
3.31V
L217
5C
PSC1
5C
REVERSE
CURRENT
PREVENTION
K
L
M
TS-480HX/480SAT
N
O
SCHEMATIC DIAGRAM
TX-RX UNIT (X57-663X-XX) (A/2)
P8C
MIC
8
R20
Q6
0.047u
2SC4617(R)
0.01V
47
R26
39p
39p
C28
18
R35
0.01u
C53
0.01u
0.047u
330p
C68
C56
390p
C62
C51
R54
560p
R53
100
100k
R49
1k
AGND
DGND
PSEL0
MCLK
82k
FSEL
SDAT
FSYNC
47
D1
KV1470
L11
C36
0.047u
2.2u
330p
R105
1k
10k
Q19
2SC4617(R)
DEN1
MUTE SW
C40
R39
220p
330
VARIABLE CAPACITANCE DIODE
0.02V
0.62V
R102
1k
R101
R34
C30
2.11V
9
1k
L7
L39-1480-05
C35
330p
0.047u
PDA
PCK
10
10
SCLK
8
R100
AMP
13
4.48V
PSEL1
7
Q2
2SC4617(R)
R18
2.74V
C26
11
6
L218
14
12
5
100u
1000p
R32
R38
10k
10k
FM MOD
MOB
DVDD
0.01u
0.047u
IOUT
15
R28
R7
330
4700p
C4
10u10
C5
10
R6
R3
0.047u
0.56V
REFO
0.047u
C23
10k
AVDD
C18
4.39V
C38
REFI
16
BUFFER
Q7
2SC4617(R)
47
COMP
C121
3.9k
0.01u
R10
C11
10u
L1
C22
FSADJ
4
1.11V
L8
10u
10u10
2
4.43V
1u
C322
10k
R316
R99
8
I5C
8C
3C
14S
Q134
13.70V
SURGE
ABSORPTION
C144
R146
LNA1
R147
R151
15k
1000p
1000p
22k
C136
C137
R134
Q135
RN1704
0V
4.7k
R:13.08V
T:13.60V
SWITCHING
C150
0.01u
C135
R142
L134
1u
R:0V
T:3.29V
LNA2
INVERTER
SPO
R148
PK5
220 C133
D138
22k
56k
1.41V
C148
100u
2.7k
7.08V
0.59V
10u10
R137
1u
R145
100
C141
4.7k
INVERTER
1.67V
Q136
2SK1824
T:0V
R149
470k
1u
LIMITER
D137
100k
3.94V
C143
0.1u
3.29V
1u
C149
470
R141
1u
C147
1u
LIMITER
1000p
1000p
C139
C138
0.21V
Q131
KRC402E
2.2
R139
100
R133
R143
Q133
UMX2N
AMP
LIMITER
C146
0.86V
LIMITER
MA2S111
REVERSE CURRENT
PREVENTION
L133
R144
470
C145
R132
R140
D134
DA221
10u10
D132
DA221
12k
1000p
GND
NC
SQC
D131
DA221
0.01u
0.01u
C134
SWITCHING
10k
1000p
C132
Q132
2SB1188(Q,R)
Q138
KRC402E
R136
GND
DTS
ANI
ANO
EXT ALC
8C
SSR
14S
R138
1000p
10k
12V
R135
100
D133
DA221
LIMITER
R:0.22V
T:0.75V
13.70V
EXT ALC
L132
10u
C142
7
3
1
5
2
4
6
TXB
R:0V
T:7.75V
10k
3.3V
2200p
500V
D136
MA2S111
K131 S51-1420-05
R:0.02V
T:0.05V
RN1704
0.01u
D139
015AZ5.1-Y
15k
C151
SWITCHING
LIMITER
R131
J132
E56-0405-05
DATA
330
C131
0.1u
C152
4.7
R153
PKD
ANO
14S
R155
1000p
REMOTE
GND
ALC
SS
SPO
MKE
COM
RL
BRK
RTK
C153
I5C
9
6
3
1
4
2
7
5
8
INVERTER
C140
J131
E56-0411-05
Q137
KRC402E
330
R154
D135
DA221
R152
8C
LIMITER
0.01u
10k
56k
R314
5
10k
R317
0.1u
R315
6
C321
7
C320
3.3k
1.58V
4.93V
AOUT
V+
1.58V
2.47V
A-IN
BOUTPUT
2.47V
A+IN
B-INPUT
0V
2.47V
VB+INPUT
10u6.3
100p
R309
0.01u
9
IC1
DDS
AD9835BRU
1
0.366Vp-p
DET
AMP
22k
C314
47p
FSYNC
P5C
REF2.5V
IC224
NJM2100V
560n
C21
C6
REF1.6V
820n
1.10V
3
RTK
82p
L19
10
FSEL
SDAT
R98
1k
PCK
PDA
DEN2
P5C
C64
33p
L15
PSEL1
SCLK
R107
1000p
7
1k
47
0.047u
BUFFER
R31
C197
R97
1.99V
100u
1000p
AMP
C25
0.047u
C60
11
MCLK
0.56V
TXC
C196
6
0.047u
56
12
CAR
390
0.344Vp-p
13
1u
DATA
PSEL0
1k
CLK
100p
AGND
DGND
47
L10
100p
C194
DVDD
5
47.1mVp-p
C37
100p
C193
4
C46
0.022u
C192
CLK
DATA
TP
C17
R36
R106
IEN1
3.72V
Q3
2SC4617(R)
BUFFER
14
FMOD
IEN1
4.18V
SM
4.09V
330
IEN2
2.61V
R30
100p
IOUT
4.01V
Q10
2SC4617(R)
C52
R61
C115
100p
C191
REFO
3
4.44V
C120
100p
C190
AVDD
C32
C189
REFI
0.047u
IEN2
0.047u
4.49V
15
330
SM
HRW
7.52V
C39
0.01u
COMP
R24
SQL
16
FSADJ
2
8.2k
CKY
SQL
1
R25
CKY
220k
15k
AMU
NFMT
RBK
1000p
10u
10u10
C44
IC2
AD9835BRU
330
FIL1
1000p
C187
R29
1000p
C186
AMU
3.9k
C185
RBK
C31
FIL1
R8
DDS
0.01u
1000p
12.5mVp-p
0.1u
R311
L6
L34-4345-05
L12
C43
L5
C184
FIL2
150p
R21
0V 3
GND
2
IN
1
NC
FIL2
RXB
AF
VOAF
14AF
14AG
SP
SPO
SMOD
DET
SPS
PHSW
TIFM
PGC
6.8k
C116
47p
4.5V
1000p
10u
C183
100p
R43
P5C
P8C
RTK
100u
122
X57-663 (A/2) 3/7
PKSR
8C
PKP
SPO
LNA2
SSR
EALC
LNA1
TXB
SQC
INVERTER
SS
R306
Q5
2SC4617(R)
TXC
3C
C310
220k
IOST
L174
10u6.3
C312
C41
10p
DOUBLER
L175
4
18
CKY
8C
3
2.2u
TCXO
10
2
L4
180
R37
18
ABK
TXC
1.58V
R19
R33
BEEP
GND
1
C34
0.047u
C14
3.60V
0.57V
C19
FMT
390
10
C16
0
4p
6.45V
R22
C29
R12
100
R13
8.2k
C8
0.01u
R11
5p
R14
P8C
15k
150p
C2
P5C
R103
R17
1000p
1000p
8p
C181
C182
10k
10u
C9
L9
L34-4345-05
C33
7.18V
BUFFER
Q4
2SC4617(R)
L3
C15
1.5u
0.047u
4.23V
R5
2.2k
FMT
10u
L172
C3
DRO
L171
UL
1.93V
39p
8C
R4
1000p
100
C180
Q1
2SC4617(R)
015AZ3.3-X
5 3.32V
VCC
VCO3
330
C313
0.01u
3C
VCO2
1000p
PKD
INVERTER
IC223
TC7S04FU
4 0V
OUT
1000p
C179
4700p
R27
VCC
3.32V
C178
VCO3
C20
G2
VCO2
22k
C24
Y1
0V 10
GND
9
A8
8
A7
7
A6
6
A5
5
A4
4
A3
3
A2
2
A1
1
G1
R313
20
Y2
VCO1
10u10
19
1000p
106mVp-p
6.72V
15.6M(B)
R23
18
Y3
C177
7.7V
7.58V
R2
NEW
2.33V
X1
15.6MHz X’tal
L77-1906-05
82k
17
D0
Y4
VCO1
PDA
0.047u
D1
Y5
DEN1
47
16
1000p
C12
15
D2
100p
C176
P8C
0
1k
14
D3
100p
C175
R15
D4
Y6
C174
PDA
DEN1
R104
Q1
CRYSTAL
OSCILLATOR
CIRCUIT
0.047u
13
D5
Y8
Y7
PCK
R16
12
PEN
C10
11
D6
DEN2
100p
PCK
UL
47k
D7
100p
C173
C1
IC222
HD74LV541AT
100p
C172
PEN
R1
BUFFER
FMOD
C171
DEN2
TC1
10p
5C
Q
R
S
TS-480HX/480SAT
SCHEMATIC DIAGRAM
RF UNIT
X44-327X-XX -CN253
RF UNIT
X44-327X-XX -CN153
CN3 LO1
E04-0191-05
CN1 LO2
E04-0191-05
R459
1k
C465
1k
0
R457
15p
R469
C468
0.01u
1k
0
390
R458
15p
R471
C464
0.01u
C469
0
390
1k
R468
C487
0.01u
1u
100p
1u
C477
UL
27p
27p
1000p
4700p
6.8k
R463
100
C476
0.1u
Q455
2SC4649(N,P)
R465
1.33V
0.01u
C118
1000p
GND
C488
39n
1000p
0.84V
0.02V
VCO OUT
12p
L466
C478
AMP
1.51V
C471
C485
L463
15k
4700p
R462
C472
C100
4700p
15k
R75
56
D4
REVERSE
CURRENT
PREVENTION
9
0.01u
51.9mVp-p
C483
6.33V
1.94V
C117
GND3
CLK
10
0
Q16
KRC418E
SWITCHING
NFMT
FMT
40.1mVp-p
OSCI
11
R90
18
270
CLK
4.99V
CE
AMP
DATA
47
R82
R86
50.3mVp-p
FIN
4.49V
VCC1
15p
R470
C484
SWITCHING
R461
47
270
DATA
PCK
PDA
PEN
C76
10u10
0.047u
8
FIN
1000p
R76
6
7
C119
R108
12
1.93V
C97
1000p
Q14
2SC4649(N,P)
R81
0.047u
FIN
5
PEN
6.8k
C79
LD
13
470
14
4
4700p
R72
3
C91
LE
10p
Q457
KRC418E
SWITCHING
R88
C89
MA2S111
FO/LD
GND2
15
10k
GND1
D456
HSC277
C486
16
R94
CPO
4.46V
VP
4.49V
VCC2
FLO
2
1.10V
1k
6.43V
D4
1
390
C463
1u
1u
36MHz~59.99MHz:0V
OTHER:3.3V
C480
1k
R89
1k
R83
47
4.49V
IC3
LMX2306TMX
R455
18p
C459
C457
C458
L465
22u
10p
C479
10p
2.2u
10u
100
L464
150n
L462
L461
Q18
UMX2N
PLL
4700p
L457
22u
C455
0.047u
6p
10p
C453
10u
C456
C474
0.047u
1k
R95
R460
22p
Q456
2SK508NV(K52)
6.15V
C473
47p
VCO3
R73
1000p
C74
SWITCHING
D455
KV1470
0.69V
DIFFERENTIAL AMP
C72
C482
VARICAP
0.02V
2.15V
Q9
4.29V
C106
0.02V
0.69V
TC453
470
R80
C94
R74
C87
10u10
10u
L27
R64
390
390p
C85
0.047u
100u
VCO3
0.68u10
680p
C69
CF1
L72-0343-05
0.033u
82
680n
C102
820n
C57
10u10
L20
470p
C63
330
R57
47 0.047u
1.78V
R79
L16
C54
0.1u35
C99
82p
L29
C481
Q9
UMX2N
0.40V
R51
27p
0.047u
C124
100k
R109
0.01u
C122
100k
Q11
2SC4617(R)
BUFFER
1.04V
C65
C123
0.01u
4.46V
C61
10k
0.01u
R52
1k
R44
10
C47
0
R45
4.40V
R58
R42
10u
1.2k
1.02V
R48
100k
Q454
KRC418E
SWITCHING
220
4.39V
HSC277
3.30V
0.01V
L35
R71
D454
10p
R464
CV
P5C
2.41V
VCO2
16MHz~35.99MHz:0V
OTHER:3.3V
SWITCHING
C467
R456
2.2u
SWITCHING
1.15V
180n
12p
100
L456
C460
L452
270
R93
R91
270
R85
6.8k
LO1 AMP
R452
HSC277
C462
Q452 27p
2SK508NV(K52)
6.15V
C452
82p
10p
4700p
D452
KV1470
D453
10p
R466
0
0.047u
47
R77
C104
R96
18
22u
10u
4.7k
C88
4700p
1k
R68
R84
15k
R92
L458
220
L454
56
C103
1000p
R453
C466
0.04V
SWITCHING
2.44V
Q453
KRC418E
VARICAP
SWITCHING
1.04V
Q451
2SK508NV(K52)
220n
TC451
68p
100n
R110
C77
R69
22p
C93
1k
47p
R70
C86
1k
R67
22p
VCO2
D2,3
14.8mVp-p
P5C
L453
2.2u
6.15V
L455
C451
120p
30kHz~15.99MHz:0V
OTHER:3.3V
1.67V
Q15
2SC4649(N,P)
1.01V
24p
18p
C81
1u
C96
R78
C83
7.21V
1000p
12p
D3
HSC277
C92
D2
HSC277
C95
10p
39n
C90
4700p
C80
1000p
L34
L31
33n
C84
270
R66
270
82n
R63
L26
82n
L23
18
100
Q13
RN47A5
SWITCHING
100
L30
R65
L451
L28
L24
C71
22n
270p
270p
22n
C67
68p
L21
R60
270
C55
0.047u
C59
R56
2.02V
LO1
56p
R451
TC452
10u10
470n
820n
2.40V
C73
D451
KV1470
10u10
C107
R87
4.7k
1000p
C98
0.1u
C101
C78
C75
12p
L25
C105
C70
8p
L22
C461
33p
VCO1
DOUBLER
Q12
2SC4617(R)
6.8k
0.047u
R47
270
C49
6.8k
R41
1.66V
C66
12p
L18
470n
1000p
Q8
2SC4617(R)
DOUBLER
2.27V
LO2
6.76V
C58
1000p
1000p
100n
L14
15k
0.047u
R55
C50
15k
L13
10u
C42
0.047u
R40
C48
4700p
C108
VARICAP
10u
7.16V
220
VCO1
6.68V
Q17
2SC4617(R)
L33
7.66V
47
R59
R46
47
7.30V
VCO2
VCO3
P8C
RIPPLE FILTER
7.61V
7.37V
VCO1
R454
LO2(B)
P8C
C470
0dBm
0.01u
-10.5dBm
56
TX-RX UNIT (X57-663X-XX) (A/2)
T
R850
P
CAR
I5C
8C
3C
14S
POC
VREF
PRO
I5C
8C
3C
14S
VSR
10k
R840
R736
22k
0.1u
C739
100k
R747
R748
B-IN 6
B+IN 5
100k
27k
2.2k
560k
METER
R749
R743
* R741
A+IN
* R772
R742
1SS388
47k
10k
0.1u
Q731
RN1704
BOUT 7
A-IN
4 GND
0V
0.02V
1k
R733
0
100k
D734
R738
R739
C736
0
3
R823
SWITCHING
015AZ6.8
VOLTAGE
SHIFT
1.8k
R774
C732
C731
IP3
3.29V
1k
IP4
0
D804
2
OP AMP
IC732
NJM2904V
1.8V
AOUT
V+ 8
0.01u
5.91V
B+IN
5.90V
B-IN
6.65V
BOUT
7.81V
V+
IC801
NJM2904V
* R826
REVERSE CURRENT
PREVENTION
R851
R839
* R821
1
2
4
D802
MA2S111
C809
0.01u
1
100k
0.02V
C807
1000p
OP AMP
0V
GND
0.21V
A+IN
0.21V
A-IN
0.65V
AOUT
LIMITER
VSRM
TCS
015AZ3.3-X
D809
0.01u
VSFM
ALC PROTECTION
C818
D808
KDS120E
REVERSE
CURRENT
PREVENTION
ALM
0.01u
7
8
470
1M
6
R827
C813
R820
33k
R811
0
R740
ALC
5
33k
IP2
VR2
4.7k
R810
R809
3
* VR1
100
R802
*
CP802
47k
C804
TCS
ALM
IC1+
IC1IC2IC2+
1000p
1000p
C803
1000p
C802
VSFM
TCS
ALM
VSFM
VSRM
1000p
C801
VSRM
VSF
VSR
ODP
EALC
IP1
REVERSE CURRENT
PREVENTION
R744
1M
R801
R808
R737
0
R822
*
D733
100k
R841
27k
R837
REVERSE CURRENT
PREVENTION
470k
33
100
R734
C733
R828
R746
18k
REVERSE CURRENT
PREVENTION
R732
R848
56k
C812
Q803
RN1701
R775
D807
KDS120E
10u6.3
1SS388
14
560
8C
0
13
D819
TEMPERATURE
COMPENSATION
0.1u
DOUT
AOUT
3.3k
AM:0V
OTHER:6.3V
0.1u
C734
D-
R853
TEMPERATURE
COMPENSATION
0.01u
A-
12
D819
D+
R824
D816
REVERSE CURRENT
PREVENTION
0V GND
A+
470
0
10k
390k
OVER DRIVE
PROTECTION
Q806
2SC4617(R)
R858
R856
R834
11
R838
1
9
10
D816
MA2S111
MA2S111
C+
0
C817
100k
R818
100k
10k
2.2k
R857
R845
C811
0.01u
2
R